Download SONY CDX-F5700, CDX-F5700X, CDX-FW570

CDX-F5700/F5700X/FW570
SERVICE MANUAL
US Model
CDX-F5700/FW570
Ver 1.0 2004. 02
Canadian Model
CDX-F5700
E Model
CDX-F5700X
Photo: CDX-F5700
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
NEW
AUDIO POWER SPECIFICATIONS (US MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD Drive Mechanism Type
MG-611MA-186//Q
Optical Pick-up Name
KSS1000E
SPECIFICATIONS
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
120 dB
10 – 20,000 Hz
Below measurable limit
Tuner section
FM
Tuning range
US, Canadian Model:
87.5 – 107.9 MHz
E Model:
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
US, Canadian Model:
530 – 1,710 kHz
E Model:
AM tuning interval:
9 kHz/10 kHz switchable
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
30 µV
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
Audio outputs terminal (front/rear)
Subwoofer output terminal (mono)
Power antenna relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
Illumination control terminal
BUS control input terminal
BUS audio input or AUX IN terminal
Remote controller input terminal
Antenna input terminal
– Continued on next page –
FM/AM COMPACT DISC PLAYER
9-877-605-01
Sony Corporation
2004B04-1
© 2004. 02
e Vehicle Company
Published by Sony Engineering Corporation
1
CDX-F5700/F5700X/FW570
Tone controls
Loudness
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
US, Canadian Model:
Bass ±10 dB at 62 Hz
Treble ±10 dB at 16 kHz
E Model:
Bass ±8 dB at 100 Hz
Treble ±8 dB at 10 kHz
+8 dB at 100 Hz
+2 dB at 10 kHz
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 177 mm
(7 1/8 × 2 × 7 in.) (w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)
Approx. 1.2 kg
(2 lb. 10 oz.)
Parts for installation and connections (1 set)
Front panel case (1)
Card remote commander RM-X114
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up
Note
This unit cannot be connected to a digital preamplifier or an equalizer which is Sony
BUS system compatible.
Design and specifications are subject to change without
notice.
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
semi-fixed resistor
• E model
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
This label is located on the bottom of the chassis.
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-F5700/F5700X/FW570
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable
CDs)
This unit can play the following discs:
Type of discs
Label on the disc
z
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Audio CD
MP3 files
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized∗.
• You can play MP3 files recorded on CD-ROMs, CD-Rs, and
CD-RWs.
• A CD-R/CD-RW to which a session can be added can be played.
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
∗ A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CN350) and the SERVO board (CN2)
with the extension cable (Part No. J-2502-076-1).
MAIN BOARD
CN350
J-2502-076-1
SERVO BOARD
CN2
3
CDX-F5700/F5700X/FW570
TABLE OF CONTENTS
1. GENERAL
Location of Controls (US, Canadian Model) .......................... 5
Location of Controls (E Model) .............................................. 5
Connections (US, Canadian Model) ........................................ 6
Connections (E Model) ........................................................... 7
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 9
2-2. CD Mechanism Block ......................................................... 9
2-3. Main Board ....................................................................... 10
2-4. Chassis (T) Sub Assy ........................................................ 10
2-5. Roller Arm Assy ................................................................ 11
2-6. Chassis (OP) Assy ............................................................. 11
2-7. Optical Pick-up ................................................................. 12
2-8. SL Motor Assy (M902) ..................................................... 12
2-9. LE Motor Assy (M903) ..................................................... 13
2-10. Servo Board ....................................................................... 13
3. DIAGRAMS
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
IC Pin Descriptions ........................................................... 14
Block Diagram –CD Section– ........................................... 19
Block Diagram –Main Section– ........................................ 20
Block Diagram –Display Section– .................................... 21
Circuit Boards Location .................................................... 21
Note for Printed Wiring Boards and
Schematic Diagrams .......................................................... 22
3-7. Waveforms ......................................................................... 22
3-8. Printed Wiring Boards –CD Mechanism Section– ............ 23
3-9. Schematic Diagram –CD Mechanism Section (1/2)– ....... 24
3-10. Schematic Diagram –CD Mechanism Section (2/2)– ....... 25
3-11. Schematic Diagram –Main Section (1/2)– ........................ 26
3-12. Schematic Diagram –Main Section (2/2)– ........................ 27
3-13. Printed Wiring Board –Main Section– .............................. 28
3-14. Printed Wiring Board –Sub Section– ................................ 29
3-15. Schematic Diagram –Sub Section– ................................... 29
3-16. Printed Wiring Board –Display Section– .......................... 30
3-17. Schematic Diagram –Display Section– ............................. 31
3-18. IC Block Diagrams ............................................................ 32
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
Main Section ..................................................................... 34
Front Panel Section ........................................................... 35
CD Mechanism Section (1) ............................................... 36
CD Mechanism Section (2) ............................................... 37
CD Mechanism Section (3) ............................................... 38
CD Mechanism Section (4) ............................................... 39
5. ELECTRICAL PARTS LIST ........................................ 40
4
CDX-F5700/F5700X/FW570
SECTION 1
GENERAL
(US, Canadian Model)
This section is extracted
from instruction manual.
(E Model)
5
CDX-F5700/F5700X/FW570
Connections (US, Canadian Model)
6
CDX-F5700/F5700X/FW570
Connections (E Model)
7
CDX-F5700/F5700X/FW570
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-1.
SUB PANEL ASSY
(Page 9)
2-2.
CD MECHANISM BLOCK
(Page 9)
2-3.
MAIN BOARD
(Page 10)
2-7.
8
2-4.
CHASSIS (T) SUB ASSY
(Page 10)
2-5.
ROLLER ARM ASSY
(Page 11)
2-6.
CHASSIS (OP) ASSY
(Page 11)
2-8.
SL MOTOR ASSY (M902)
(Page 12)
OPTICAL PICK-UP
(Page 12)
2-10. SERVO BOARD
(Page 13)
2-9.
LE MOTOR ASSY (M903)
(Page 13)
CDX-F5700/F5700X/FW570
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
3 two claws
4
2 two claws
CN370
1 two screws
(+PTT 2.6 x 6)
5 sub panel assy
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 two screws
(+PTT 2.6 x 4)
2 screw
(+PTT 2.6 x 6)
3
1 screw
(+PTT 2.6 x 6)
4 CN350
9
CDX-F5700/F5700X/FW570
2-3. MAIN BOARD
1 three ground point screws
(+PTT 2.6 x 6)
5 screw
(+PTT 2.6 x 6)
4 CN410
6 cord (RCA)
2 two screws
(+PTT 2.6 x 6)
3 MAIN board
insulating sheet
2-4. CHASSIS (T) SUB ASSY
4 claw
2 two screws
(+P 1.7 x 2.2)
1 two screws
(+P 1.7 x 2.2)
6 chassis (T) sub assy
5 SENSOR board
3 claw
10
CDX-F5700/F5700X/FW570
2-5. ROLLER ARM ASSY
3 washer
5 roller arm assy
4 worm wheel (RA)
2 spring (RAR)
1 spring (RAL)
2-6. CHASSIS (OP) ASSY
8
qa chassis (OP) assy
0 coil spring (damper)
lever (D)
4 washer
1 CN1
6
9 two coil springs (damper)
5 gear (LE1)
7
slider (R)
3 tension coil spring (KF)
2 Remove the six solderings.
11
CDX-F5700/F5700X/FW570
2-7. OPTICAL PICK-UP
2 chucking arm sub assy
5 claw
1 tension coil spring (CHKG)
7 optical pick-up
6 main shaft
4 rack (SL)
3 screw
(+B 1.4 x 5)
2-8. SL MOTOR ASSY (M902)
1 screw
(+P 1.4 x 1.8)
2 SL motor assy (M902)
12
CDX-F5700/F5700X/FW570
2-9. LE MOTOR ASSY (M903)
8 screw
(+M 1.7 x 2.5)
0 woam (LEB) assy
9 bearing (LEB)
qf two toothed lock screws
(+M 1.4 )
2 washer
qa screw
(+M 1.7 x 2.5)
3 gear (LE1)
lever (D)
4
bracket (LEM)
qs screw
(+M 1.7 x 2.5)
qd
qg LE motor assy
(M903)
5
6 screw
(+P 1.7 x 2.2)
slider (R)
7 leaf spring (LE)
1 Remove the soldering.
2-10. SERVO BOARD
1 Remove the eight solderings.
6 SERVO board
2 Remove the three solderings.
4 toothed lock screw
(M 1.7)
5 claw
3 CN1
13
CDX-F5700/F5700X/FW570
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC3 CXD3059BR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2))
Pin No.
Pin Name
I/O
Pin Description
1
MIRR
I/O
Mirrer signal input/output
14
2
3
DFCT
FOK
I/O
I/O
Defect signal input/output
Focus OK signal input/output
4
5
VSS
LOCK
—
I/O
Ground pin
Not used in this set. (Open)
6
7
MDP
SSTP
O
I
Spindle motor servo control signal output
Disc most inner detection signal input
8
9
IOVSS1
SFDR
—
O
Digital ground pin for I/O
Sled drive signal output
10
11
SRDR
TFDR
O
O
Sled drive signal output
Tracking drive signal output
12
13
TRDR
FFDR
O
O
Tracking drive signal output
Focus drive signal output
14
15
FRDR
IOVDD1
O
—
Focus drive signal output
Digital power supply pin for I/O
16
17
AVDD0
AVSS0
—
—
Analog power supply pin
Analog ground pin
18
19
NC
E
—
I
Not used. (Open)
E signal input
20
21
F
TEI
I
I
F signal input
Tracking error signal input from the DSSP block
22
23
24
TEO
FEI
FEO
O
I
O
Tracking error signal output to the RF amp block
Focus error signal input from the DSSP block
Focus error signal output to the RF amp block
25
VC
I/O
26
27
A
B
I
I
A signal input
B signal input
28
29
C
D
I
I
C signal input
D signal input
30
31
NC
AVDD4
—
—
Not used. (Open)
Analog power supply pin
32
RFDCO
I/O
RFDC signal output
RFDC signal input from the DSSP block by command select
33
34
PDSENS
AC SUM
I
O
Reference voltage input for PD
RFAC suming amp signal output
35
36
EQ IN
LD
I
O
Equalizer circuit signal input
APC amp signal output
37
38
PD
NC
I
—
APC amp signal input
Not used. (Open)
39
40
RFC
AVSS4
I
—
EQ cut off frequency adjustment input
Analog ground pin
41
42
RFACO
RFACI
O
I
RFAC signal output
RFAC signal input or EFM signal input
43
44
AVDD3
BIAS
—
I
Analog power supply pin
Asymmetry circuit constant current input
45
46
ASYI
ASYO
I
O
Asymmetry comparate voltage input
EFM full swing signal output
47
48
VPCO
VCTL
O
I
Charge pump output for wideband EFM PLL
VCO2 control voltage input for wideband EFM PLL
49
AVSS3
—
Analog ground pin
VC voltage output to the RF amp block
Center voltage input from the DSSP block by command select
CDX-F5700/F5700X/FW570
Pin No.
50
Pin Name
CLTV
I/O
I
Pin Description
51
52
FILO
FILI
O
I
Filter signal output for master PLL
Filter signal input for master PLL
53
54
PCO
AVDD5
O
—
Charge pump output for master PLL
Analog power supply pin
55
56
DDVROUT
DDVRSEN
O
I
DC/DC converter output
DC/DC converter output voltage monitor signal input
57
58
AVSS5
DDCR
—
I
Analog ground pin
Reset signal input for DC/DC converter
59
60
NC
BCKI
—
I
Not used. (Open)
D/A interface bit clock signal input
61
62
PCMDI
LRCKI
I
I
D/A interface serial data signal input
D/A interface LR clock signal input
63
64
LRCK
VSS
O
—
D/A interface LR clock signal output
Digital ground pin for internal
65
66
PCMD
BCK
O
O
D/A interface serial data signal output
D/A interface bit clock signal output
67
68
VDD
EMPH
—
O
Digital power supply pin for internal
Not used in this set. (Open)
69
70
EMPHI
IOVDD2
I
—
Not used in this set. (Fixed at “L”.)
Digital power supply pin for I/O
71
72, 73
DOUT
TEST
O
I
Digital out signal output
Test pin Normally “L”.
74
75
76
IOVSS2
NC
XVSS
—
—
—
Digital ground pin for I/O
Not used in this set. (Open)
Ground pin for master clock
77
78
XTAO
XTAI
O
I
Crystal oscillation circuit output (16.9344 MHz)
Crystal oscillation circuit input (16.9344 MHz)
79
80
XVDD
AVDD1
—
—
Power supply pin for master clock
Analog power supply pin
81
82
AOUT1
VREFL
O
O
L channel analog signal output
L channel reference voltage output
83
84
AVSS1
AVSS2
—
—
Analog ground pin
Analog ground pin
85
86
VREFR
AOUT2
O
O
R channel reference voltage output
R channel analog signal output
87
88
AVDD2
NC
—
—
Analog power supply pin
Not used. (Open)
89
90
IOVDD0
RMUT
—
O
Digital power supply pin for I/O
R channel “0” detection flug output
91
92
LMUT
NC
O
—
L channel “0” detection flug output
Not used. (Open)
93
94
XTSL
IOVSS0
I
—
X’tal select signal input 16.9344 MHz: “L”, 33.8688 MHz: “H”
Digital ground pin for I/O
95
96
XTACN
SQSO
I
O
Oscillation circuit control input “H”: Oscillation start, “L”: Oscillation stop
Sub 80 bit and PCM peak, level data signal output CD text data signal output
97
98
SQCK
SBSO
I
O
Clock signal input for SQSO read out
Sub P-W serial data signal output Not used in this set. (Open)
99
100
EXCK
XRST
I
I
Clock signal input for SBSO read out
System reset signal input “L”: reset
101
102
SYSM
DATA
I
I
Mute signal input “H”: mute
Serial data signal input
103
VSS
—
Digital ground pin for internal
VCO1 control voltage input
Not used in this set. (Open)
Not used in this set. (Fixed at “L”.)
15
CDX-F5700/F5700X/FW570
Pin No.
104
Pin Name
XLAT
I/O
I
Latch signal input
105
106
CLOK
VDD
I
—
Serial data transfer clock signal input
Digital power supply pin for internal
107
108
SENS
SCLK
O
I
SENS signal output
Clock signal input for SENS serial data read out
109
110
ATSK
WFCK
I/O
O
Input/output for anti-shock
WFCK signal output Not used in this set. (Open)
111
112
XUGF
XPCK
O
O
XUGF signal output Not used in this set. (Open)
XPCK signal output Not used in this set. (Open)
113
114
GFS
C2PO
O
O
GFS signal output
C2PO signal output
115
116
SCOR
VDD
O
—
Sub code sync signal output
Digital power supply pin for internal
117
118
C4M
WDCK
O
O
4.2336 MHz signal output Not used in this set. (Open)
Word clock signal output Not used in this set. (Open)
119
120
COUT
NC
I/O
—
16
Pin Description
Track count signal input/output
Not used. (Open)
Not used in this set. (Open)
CDX-F5700/F5700X/FW570
• IC600 MN101E01KDG (SYSTEM CONTROL) (MAIN BOARD (2/2))
Pin No.
Pin Name
I/O
Pin Description
1
DAVDD
—
Power supply pin for D/A output converter (+3.3 V)
2
3
NCO
DAVSS
O
—
Not used in this set. (Open)
Ground pin for D/A output converter
4
5
UNISO
UNISI
O
I
SONY-BUS data signal output
SONY-BUS data signal input
6
7, 8
UNICKO
RE 0, RE 1
O
I
SONY-BUS clock signal output
Rotary encoder signal input
9
10
ILLIN
VDD1
I
—
Illumination signal input for auto dimmer H: Ill off, L: Ill on
Power supply pin for internal core (+3.3 V)
11
12
MMOD
OSCOUT
I
O
Flash microcomputer write detection signal input
High speed operation clock signal output (27.648 MHz)
13
14
OSCIN
VSS1
I
—
High speed operation clock signal input (27.648 MHz)
Ground pin for internal core
15
16
XIN
XOUT
I
O
Low speed operation clock signal input (32.768 kHz)
Low speed operation clock signal output (32.768 kHz)
17
18
VDD2
MOD1
—
—
Power supply pin for internal core (+3.3 V)
Pull up: “H”
19
20
RESET
RCIN1
I
I
Reset signal input
Rotary shift commander shift key signal input
21
22
ACC IN
TEST IN
I
I
Accessory power supply detection signal input
Test mode detection signal input
23
24
TEL ATT
ATT
I
O
Telephone attenuate detection signal input
Audio mute control signal output
25
26
27
ADON
NCO
KEYACK
O
O
I
A/D converter power supply control signal output
Not used in this set. (Open)
Key acknowledge detection signal input
28
29
TU ATTIN
CDON
I
I
Tuner mute ZERO cross detection signal input
CD mechanism servo power supply control signal input
30
31
CDMON
BUIN
I
I
CD mechanism loading +6V power supply control signal input
Back up power supply detection signal input
32 to 35
36
NCO
BUSON
O
O
Not used in this set. (Open)
BUS on signal output
37
38 to 41
SYSRST
NCO
O
O
System reset signal output
Not used in this set. (Open)
42
43 to 48
Z MUTE
NCO
I
O
CD mechanism zero cross mute detection signal input
Not used in this set. (Open)
49
50
ILL VSEL
BBE SEL
O
I
Not used in this set. (Open)
BBE with/without setting pin L: with, H: without Not used in this set. (Open)
51
52
AREASEL2
AREASEL1
I
I
Destination function setting input 2 Not used in this set. (Open)
Destination function setting input 1
53
54 to 57
AREASEL0
NCO
I
O
Destination function setting input 0
Not used in this set. (Open)
58
59
DOOR SW
DIAG
I
I
Front panel open/close detection signal input “L”: Panel close, “H”: Panel open
Condition signal input from the power IC
60
61
VOLATT
NOSE SW
O
I
Electronic volume attenuate control signal output
Front panel attachment detection signal input L: Panel on
62
63
AUX IN
VSS2
O
—
AUX light change signal output
Ground pin for I/O port
64
65
TU ATT
NCO (TUON)
O
O
Tuner mute control signal output
Not used in this set. (Open)
66
67
NS MASK
E2P CKO
O
O
AEP, UK model: Noise mask signal output US, Canadian, E model: Not used. (Open)
Serial clock signal output for EEPROM communication
L: AUX, H: BUS in
17
CDX-F5700/F5700X/FW570
Pin No.
68
Pin Name
E2P SIO
I/O
I/O
69
70
DOORIND
AMPSTB
O
O
Sub panel power supply control signal output
Power regulator IC standby signal output
71
72
NCO
LCDSO
O
O
Not used in this set. (Open)
Serial data signal output to the LCD driver
73
74
LCDCE
LCDCKO
O
O
Chip enable signal output to the LCD driver
Serial clock signal output to the LCD driver
75 to 78
79
NCO
I2C SIO
O
I/O
80
81
NCO
I2C CKO
O
O
Not used in this set. (Open)
I2C BUS serial clock signal output
82
DAVN
I
AEP, UK model: RDS data block synchronization detection signal input
US, Canadian, E model: Not used. (Open)
83
84
SIRCS
NCO
I
O
Remote control signal input
Not used in this set. (Open)
85
86 to 88
BEEP
NCO
O
O
Beep signal output to the power amp
Not used in this set. (Open)
89
90
VDD3
NCO
—
O
Power supply pin for I/O port (+3.3 V)
Not used in this set. (Open)
91
92
VSS3
QUALITY
—
I
Ground pin for I/O port
AEP, UK model: Noise detection signal input US, Canadian, E model: Not used. (Open)
93
94
VSM
KEYIN1
I
I
S meter voltage detection signal input
Key signal input 1
95
96
97
KEYIN0
RCIN0
SA IN
I
I
I
Key signal input 0
Rotary commander signal input
Spectrum analyzer signal input
98
99
SA CLK
NCO
O
O
Spectrum analyzer clock signal output
Not used in this set.
100
VREF+
—
Power supply pin for A/D input converter
18
Pin Description
Serial data signal input/output for EEPROM communication
Flash: UART serial output
Flash: Serial input
Not used in this set. (Open)
I2C BUS serial data signal input/output
CDX-F5700/F5700X/FW570
3-2. BLOCK DIAGRAM — CD SECTION —
• R-ch is omitted due to same as L-ch.
• Siganal Path
: CD PLAY
DETECTOR
PD1
PD2
PD2
26 A
PD1
42 RFACI
RFACO 41
ASYO 46
45 ASYI
AOUT2 86
27 B
CD-L
AOUT1 81
A
MAIN
SECTION
(Page 20)
R-CH
28 C
I-V AMP
29 D
E
E
F
F
RF AMP,DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC3
19 E
FEO 24
23 FEI
20 F
TEO 22
21 TEI
PD
LD
AUTOMATIC
POWER
CONTROL
Q1
36 LD
PD 37
PD
RMUTE 90
23 CD RMUT
19
16
18
15
14
13
12
11
10
8
7
52
3
96
97
100
102
104
105
107
108
113
114
115
CD FOK
CD SQSO
CD SQCK
CD XRST
CD DATA
CD XLAT
CD CLOK
CD SENS
CD SCLK
CD GFS
CD C2PO
CD SCORT
UNISI
RXD
UNISO
TXD
UNICLK
BUS ON
BU IN
RSTX
A ATT
LINK OFF
UNI SI
56
25
57
26
58
50
51
75
60
20
UNI SO
UNI SCK
BUS ON
BU IN
SYS RST
ATT
LINK OFF
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING
MOTOR DRIVE
IC1
EJECT OK 61
58 DOOR W
MECON 63
CDON 64
ZMUT 66
30 CDM ON
29 CD ON
42 Z MUTE
FCS–
11 VO2–
VIN2+ 22
13 FFDR
10 VO2+
VIN2– 21
14 FRDR
13 VO1–
VIN1+B 19
11 TFDR
12 VO1+
VIN1–B 18
12 TRDR
+1.5V REG
IC7
X2
18.43MHz
XTAO 77
80 X0
+1.5V
(FOCUS)
+1.5V
CONTROL
Q2,3
5 VOUT
VDD 1
CE 3
(TRACKING)
TRK+
TRK–
SW1
(DOWN)
46 MEC_DSW
+3.3V
M902
(SLED)
M
M901
(SPINDLE)
M
M903
(LOADING)
M
6 VO4+
VIN4+ 31
9 SFDR
7 VO4–
VIN4– 32
10 SRDR
8 VO3+
VIN3+ 25
6 MDP
BCK
BCKI
PCMDI
LRCK
LRCKI
PCMD
66
60
61
63
62
65
9 VO3–
5 VLO+
4 VLO–
SW2
(SELF)
53 MEC_SELFSW
45 MEC_INSW
SW4
(LIMIT)
42 MEC_LIMIT
MUTE 34
41 DRON
FWD 1
43 MEC LOAD
REV 2
44 MEC EJECT
19
+3.3V
CONTROL
Q5,6
DECON 65
SW3
(DISC IN)
19
(Page 20)
SERVO+3.3V
81 X1
X1
16.934MHz
MAIN
SECTION
MECHA+6V
CDON CHK 68
XTAI 78
FCS+
B
SYSTEM CONTROL
IC600 (1/3)
CD
SYSTEM CONTROL
IC4
MECON CHK 67
OPTICAL
PICK-UP BLOCK
(KSS1000E)
2-AXIS DEVICE
22 CD LMUT
FOK
SQSO
SQCK
XRST
DATA
XLAT
CLOK
SENS
SCLK
GFS
C2POT
SCOR
LASER DIODE
LD
LMUTE 91
AUDIO INTERFACE
IC8
DEC XMUTE
DEC SSTBY
DEC XRST
DEC STBY
DEC INT
DEC SCL
DEC SDA
EMPH
37
27
28
29
30
31
32
69
22
41
2
3
36
7
6
28
CLCK
SRMSTB
RESET
STANDBY
BUCK
I2C SCL
I2C SDA
BUSO
15
18
11
16
19
14
BCK1A
BCK1B
SD0O
LRCK1A
LRCK1B
SD1O
U COM+3.3V
CDX-F5700/F5700X/FW570
3-3. BLOCK DIAGRAM — MAIN SECTION —
SOUND CONTROL,
ELECTRONIC VOLUME
IC351
J451(2/2)
OUTLR 24
L
MUTE
Q452
J451(1/2)
L
R-CH
BUS
AUDIO IN
R
R-CH
MUTE
Q440
BUS AUDIO
SELECT SWITCH
Q351
CD
SECTION
A
CD-L
L
R-CH
(Page 19)
L 4
R 3
42 IN3L
43 IN3R
R
MUTE
Q352
40 IN4L
41 IN4R
11 IN-RL
VCC 10
VDD+5V 11
E2P VDD 15
SCL 13
SDA 14
AUDIO+8.3V
14 SACLK
16 SAOUT
TU+5V
BACK UP+3.3V
R-CH (FRONT)
R-CH (REAR)
SCL 13
SDA 12
2
OUT-RL+ 9
OUT-RL– 7
MUTE 15
MUTE DRIVE
Q491,492
SCL
SDA
10
D491
POWER AMP,
MULTIPLE VOLTAGE
REGULATOR
IC300
BATT
SCL
SDA
SYSTEM CONTROL
IC600 (2/3)
97 SAIN
98 SACLK
62 AUXIN
ATT
BEEP
AMPSTB
DIAG
KEYACK
SDA
SCL
SCL
SDA
D495
SUB
(M0N0)
OUT
RL+
RL–
4
FR+
12
FR–
3
RR+
11
RR–
R-CH
5
AMP-REM
6
ANT-REM
AMP-REM 29
ANT-REM 27
I2C CKO 81
I2C SIO 79
VOL ATT 60
AUDIO OUT
FRONT
CN300
1
FL+
9
FL–
OUT-FL+ 5
OUT-FL– 3
12 IN-FL
OUTRF 22
OUTRR 21
AUDIO OUT
REAR
CN410
OUTSW 17
TU1
(TUNER UNIT)
1 ANT
L
OUTLF 25
R-CH
R
J1
(ANTENNA)
4 IN1L+
7 IN1R+
5 IN1-
R
R-CH
F901
2 SDA
4 SCL
BATT
16
BATT
D494
24
85
70
59
27
AUDIO+B
BU+B
SERVO+3.3V
MECHA+6V
PANEL+B
16 BEEP
22 STB
25 DIAG
BATT
30
37
31
33
34
AUDIO+8.3V
BACK UP+5V
SERVO+3.3V
MECHA+6V
PANEL+9V
35 VP
KEY ACKNOWLEDGE SWITCH
Q501
ADON 25
7
ACC CHECK
Q702
ACC IN 21
ILL CHECK
Q703
ILL IN 9
ACC
14
ILL
13
TEL ATT
Q701
TEL ATT 23
15
TEST IN 22
RCIN1 20
RCIN0 96
ATT
TEST
J390
(REMOTE IN)
BUS INTERFACE
IC601
S-METER 6
TU MUTE 7
93 VSM
64 TU ATT
E2P SCL 16
E2P SDA 17
67 E2P CKO
68 E2P SIO
D609
CD
SECTION
B
BUS ON
SYS RST
D353
(Page 19)
10
13
12
11
8
9
BUIN
BATT 3
RST
BUS IN
CLK IN
CLK 4
DATA OUT
DATA I/O 6
DATA IN
BUS ON 1
D610
4
5
6
36
37
UNI SO
UNI SI
UNI SCK
BUIN 31
UNI SO
UNI SI
UNI SCK
BUS ON
SYS RST
C
D602
BATT
8
4
5
6
BUS ON
SWITCH
Q600,601
3
2
1
CNJ400
(BUS CONTROL IN)
• R-CH is omitted due to same as L-CH.
• Signal Path
: CD PLAY
7
: FM
BATT
RST 2
D354
BU IN
ATT
LINK OFF
DISPLAY
SECTION
OVER VOLTAGE
DETECT
Q605
RESET
(Page 21)
20
20
: AM
TH400
: BUS AUDIO
TU+5V
TU+5V REG
Q3
AUDIO+8.3V
BACK UP+3.3V
+3.3V REG
IC501
BACK UP+5V
CDX-F5700/F5700X/FW570
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
SYSTEM CONTROL
IC600 (3/3)
ROTARY
ENCODER
S921 (1/2)
3-5. CIRCUIT BOARDS LOCATION
LCD DRIVER
IC901
7 RE 0
8 RE 1
LCD SO 72
LCD CKO 74
LCD CE 73
KEY MATRIX
S911-920,
S921 (2/2)
94 KEYIN1
KEY MATRIX
S801,S901-910
95 KEYIN0
100 LCD DATA
99 CLK
LCD CLK
98 CE
LCD CE
SERVO board
SENSOR board
SEG01 15
I
I
SEG16 30
•
SEG17 33
I
I
SEG70 86
LCD901
LIQUID
CRYSTAL
DISPLAY
PANEL
COM1 90
I
|
COM4 87
DIMMER 1
DIMMER
CONTROL
Q906-908
tuner unit
(TU1)
LED801,802
DOOR IND
SWITCH
Q101
69 DOORIND
AMBER2
AMBER1
BLUE1
GREEN2
GREEN1
RESET
IC602
BACK UP+3.3V
2 IN
VOUT 1
LED931-934
LCD
( BACK LIGHT )
2
3
4
5
6
MAIN board
DISPLAY board
LED DRIVE
Q901-905
SUB board
PANEL+5V
19 RESET
S103
(RESET)
MAIN
SECTION
C
LED901-922
RESET
(Page 20)
3
61 NOSESW
+3.3V
REG
IC981
2
PANEL+5V
S102
(NOSE DET)
F5700X
S501
FREQUENCY
SELECT
10k
BACKUP+3.3V
SIRCS 83
1
VCC
2 OUT
IR
REMOTE CONTROL
SIGNAL RECEIVER
IC971
53 AREASELO
9k
X501
32.768kHz
15 XIN
16 XOUT
OSCIN 13
OSCOUT 12
X500
27.648MHz
21
21
CDX-F5700/F5700X/FW570
3-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
3-7. WAVEFORMS
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
— Servo Board —
1
For schematic diagrams.
For printed wiring boards.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
: internal component.
•
• C : panel designation.
Note:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
: Through hole.
•
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
•
•
•
•
•
•
•
•
•
•
•
Note:
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
A : B+ Line.
B : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
CD mechanism section (1/2), (2/2)
no mark : CD PLAY
Main (1/2), (2/2) and Display sections
no mark : FM
(
) : AM
<
> : CD PLAY
∗
: Impossible to measure
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
J : CD PLAY
F : FM
f : AM
L : BUS AUDIO
Abbreviation
CND : Canadian model.
— Main Board —
(MODE: CD PLAY)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
1
27.648MHz
Approx. 100mVp-p
(TEI)
wa
IC3
IC600
2
qs
(OSCOUT)
2
1.8Vp-p
0V
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
32.768kHz
Approx. 100mVp-p
IC600
(FEI)
wd
IC3
3
Approx.
150mVp-p
C
Q
2.2Vp-p
0V
These are omitted
B E
IC3
wh (A), wk (C)
4
Approx.
150mVp-p
BE C
These are omitted
IC3
wj (B), wl (D)
5
ECB
Approx.
0.8Vp-p
These are omitted
• Abbreviation
CND : Canadian model.
ra
IC3
(RFACO)
6
2Vp-p
16.9344MHz
IC3
uj
(XTAO)
7
1Vp-p
18.43MHz
IC4
22
22
ia
(X1)
qh
(XOUT)
CDX-F5700/F5700X/FW570
3-8. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Circuit Boards Location.
2
1
R107
7
8
9
10
C47
C44
C43
C49
R68
C59
R67
R71
R98
R1
C4
C107
R80
R129
R62
R59
R50
R52
R143
C53
R48
C48
B7
R64
R128
R110
C58
FM
R142
C86
R126
R145
C81
C75
C55
R78
R79
R122
C57
R99
R144
R72
R70
C54
C65
C115
C64
C77
R61
R111
R108
C10
R56
C50
R49
C110
R97
R141
SW3
C5
R119
R73
FB2
R115
C32
E
R74
1
C66
CN
R81
IC4
R37
C109
R46
R54
C79
C37
R44
R55
X1
BP1
R127
R60
IC8
IC3
R12 R7
C45
R43
R77
C
R13
C27
C6
C40
R42
R45
C42
R109
R8
R20
Q1
C38
C46
C39
R41
R149
C35
R38
C41
C91
C34
Q3
R24
R40
C85
R140
14
R28
C30
R25
C33
IC7
R116
SW2
R87
R57
C67
FB1
R147
R123
R146
R26
R17
R4
C8
C19
R27
C26
C7
R21
R5
C63
R148
R16
R18
C51
CN2
R133
R114
R86
FB5
R124
R39
C60
R136
R92
R91
R47
C56
C36
R117
B8
X2
C2
R69
FM
R85
R65
C1
F
13
R2
R9
R19
C25
R23
R22
C28
D
12
R3
BP2
R53
C29
R29
C92
11
BP3
R76
C22
Q2
C23
C24
R101
R139
R106
C74
6
Q5
C83
B
5
R6
Q6
4
C52
A
3
: Uses unleaded solder.
C18
(Page 28)
G
C21
IC1
C3
R15
R14
C13
C14
R11
C11
C16
R10
SW1
H
• Semiconductor
Location
Ref. No. Location
IC1
G-2
IC3
C-10
IC4
E-2
IC7
B-2
IC8
C-2
Q1
Q2
Q3
Q5
Q6
23
23
C-4
B-2
B-2
A-2
A-2
CDX-F5700/F5700X/FW570
3-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 22 for Waveforms.
R67
R60
R56
TP141
TP137
TP116
TP127
R59
R52
C41
R40
TP98
R50
TP97
TP94
TP96
R149
R48
TP65
TP343
TP63
TP62
C33
TP344
C45
R71
C54
TP59
TP60
TP57
R64
TP61
C52
C58 TP180
C60
R97
R29
C53
C59
TP181
R98
CN2
C29
IC3
R70
C28
C81
TP129
TP72
TP123
R77
TP128
TP139
TP53
X1
TP56
TP140
R13
R6
R22
C22
C23
C24
C25
CN1
TP21
TP167
FB2
TP48
R24
FB5
TP49
TP71
BP3
R25
R23
TP175
R78
R76
R79
TP24
TP25
R68
R1
R72
C6
R133
TP42
R124
TP51
TP37
TP41
TP132
TP36
TP39
TP38
TP43
C50
R54
R45
R43
C42
R41
C48
C47
R53
C44
R46
C43
C38
R44
C30
C10
C46
C64
(Page 25)
24
24
R61
C49
R55
R49
R12
R38
R7
C40
TP45
C37
C39
TP44
C34
C35
Q1
TP99
TP33
C5
TP135
TP46
TP32
TP34
TP35
TP133
TP136
R42
C4
TP47
C57
R114
TP50
C27
TP28
TP29
TP30
TP55
TP54
C55
BP2
TP22
TP23
TP26
TP27
R65
C65
C107
TP40
(Page 27)
CDX-F5700/F5700X/FW570
• Refer to page 22 for Waveform.
3-10. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 32 for IC Block Diagrams.
(Page 24)
FB1
R146
R47
R73
R69
C56
R57
R39
R148
C36
R147
R136
C67
R91
R81
R92
TP7
SW4
C63
TP8
R15
R117
R14
X2
TP9
C1
IC B/D
C2
IC1
R85
R86
TP11
SW3
C32
R37
R87
TP12
SW2
C21
C3
TP19
SW1
TP20
R140
IC4
C11
R18
C19
R20
C66
R19
TP17
R17
C18
M903
R145
R123
TP18
R141
TP58
R142
R143
R21
TP13
M901
TP15
R16
M902
C7
R4
R2
TP52
R74
R80
R62
R128
R129
R5
C14
R127
R3
C8
R122
R9
R126
C16
R11
R115
R28
R119
C51
R8
C13
R10
C86
C115
R111
R110
C92
C77
C75
C109
R99
R144
R108
C79 TP226
BP1
IC8
R109
C110
IC B/D
TP230
IC7
TP231
Q5
Q3
C83
R101
C85 R106
R107
R139
Q6
TP249
TP16
R26 R27
C26
TP14
TP31
C74
R116
C91
25
Q2
25
CDX-F5700/F5700X/FW570
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 32 for IC Block Diagrams.
C303
*3
C302
L902
0
(F5700/FW570)
2.2 (F5700X)
C308
JC302
C306
C304
C305
C307
C309
*
C424
2.2
C444
L902 3
J451
C301
L901
C317
IC B/D
C423
C443
CN410
R423
R443
C442
C422
C452
C432
C413
C414
C369
IC300
J1
C319
R433
R302
R453
Q440
Q420
Q452
Q352
Q432
JC52
R301
C454
C318
C433
C434
C453
TU1
C372
CN300
R452
R447
R448
R449
R442
R421
R451
C441
C421
C451
Q351
R450
R361
R431
C371
C431
D302
D301
C315
C316
D352
C368 R360
C320
R701
C313
R4
C310
R5
C314
D303
C360
D304
R445
R446 R353 C359
R362
C901 D308 D307 D306 D305
R354
R702
C701
L300
R364
D707
R709
D706
D312 D311 D310 D309
C902
R710
R705
Q3
C2
R703
D703
R708
Q701
D704
D701
D702
Q703
R357
R359
R358
C6 C5
R10
*
C9
R352
Q492
C702
D495
R355
R356
C365
C367
R12
D2
R13
C358
C357
C703
R712
R706
C366
IC351
C491
L4
R363
D494
R704
R6
R365
2
*
R7
C355
*1
Q492
DTC144EKA (F5700/FW570)
DTC114EKA (F5700X)
*2
R365
0 (F5700/FW570)
4.7 (F5700X)
IC B/D
C351
C352
C362
C354
C356
C353
C363
(Page 27)
26
C3
C7
Q491
1
R491 D491
R707
D705 R711
R444
R441
Q702
D607
C704
F901
C312
26
F5700/FW570
C364
C361
C4
1000p
F5700X
C8
CDX-F5700/F5700X/FW570
• Refer to page 22 for Waveforms.
3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 33 for IC Block Diagram.
(Page 26)
IC501
Q501
R531
R517
R542
C506
R514
R546
(Page 24)
C502
R544
S501
R545
C501
R516
C504
R537
CN350
R512
R520
R511
R536
C417
C412
R510
C403
R523 R524
IC602
R509
C405
L402
L407
L403
R547
L409
R402
C407
C512
R549
L410
C416
L405
C513
R508
R548
L401
L408
L404
X501
R401
R525
C511
C510
R560
L406
C507
IC600
R506
C409
R351
C505
R513
C415
C420
R507
L501
R561
X500
R535
C402
R503
R532
C401
R530
R533
R528
D353
D354
R500
C500
R529
R522
R518
C904
R538
R501
R534
D501
R526
R527
C514
C515 C516 C517 C521
C519
D101
R603
D103
R604
C518
D602
R110
R608
R111
D603
Q600
R101
Q101
L100
Q601
CNJ400
R112
R610
D106
R102
R113
C601
R103
R602
R606
S103
R104
S102
R108
R601
R611
R607
R109
R115
JC110
R105
C330
R106
(Page 29)
D610
C600
R107
D605
D606
R116
C329
D901
D604
D609
IC601
C325
L301
J370
L302
R371
L303
R370
CN370
R120
Q605
TH400
R121
IC B/D
D102
27
27
CDX-F5700/F5700X/FW570
3-13. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 21 for Circuit Boards Location.
1
2
3
4
5
6
: Uses unleaded solder.
7
8
9
10
11
12
13
14
J451
J1
A
J370
L301
C329
D901
C305
R712
C703
D311
JW78
IC601
JW26
R602
R601
JC501
JW22
R112
(Page 29)
28
28
JW21
JW19
S103
JW20
R535
C507
JW17
R500
R113
S102
R371
• Semiconductor Location
R370
R610
JC601
JW25
JW28
JW27
D610
R604
R603
L408
JW63
R707
JC101
JC702
JW29 JW31
JW33
JW32
Q600
JC605
L404
C415
C401
C702
R706
R708
R703
R509
C513
R608
JW58
C601 D604
FMB4
D602
C412
JW57
JC51
R704
JC508
JW24
JW59
D609
R507
R532
C521
JC509
L302
L303
D607
L403
C405
C417
C403
C364
C363
JC510
JW34
JW56
R514
R506
IC602
D603
JW79
JC408
C491
R518
JW15
C518
JW61
R701
R711
JW301
JW120
D312
C506
JW94
C504
JW87
JW86
C514
C515
C516
JW14
JW10
X500
JW39
D106
R120
D103
X501
Q601
JC703
JW16
R522
R533
JW43
R101
JC105
L100
R110
JC704
L501
R121
JC103
D101
D102
CN370
R510
Q702
JC608
JW65
JW127
R351
R530
C500
R501
R534
JW129
JC502
JC104
R102
R527
R111
R115
JW2
C501
C502
JW88
R547
JW35
JW36
R549
Q101
JW37
R103
JW137
L406
C409
JW60
R536
R508
D501
C519
I
R104
JC604
R511
R537
IC600
C512
D354
R513
Q501
R561
C517
R116
R105
R512
JW3
JW66
L405
D353
R525
C420
JC512
JW12
R109
C330
C325
R560
Q701
Q605
C407
C416
D495
JW54
JW53
C904
JW51
JC110
JW7
JC109
JW6
JW4
R106
JW38
R108
JC108
R528
JC16
R107
R529
C319
R538
R526
R302
H
JC505
FMB3
R548
JW50
JW5
R523
R524
JW69
JW67
D494
JW18
JW40
JW52
JC506
JW134
R364
JW62
JW68
C402
R546
R520
JW70
L407
R401
R542
(Page 23)
C600
JW71
L410
JW85
R516
JC507
JW8
JW105
JC503
C511
R362
JW49
JW42
JW48
JW47
JW106
R705
R531
R517
TH400
JW73
R402
C510
C5
JC17
C4
R544
Q703
L402
JW81
S501
R545
JW76
CN350
JW84
R7
F5700/FW570
L401
JW80
JW83
Q3
JC52
JW121
JW118
JW119
D309
D306
D310
D305
Q492
JW82
JW91
L300
R702
C316
IC501
JW90
L4
R6
L409
JW93
C353
C704
D303
JW72
JW89
JW133
R709
JW117
JW115
JW116
JW114
D307
D308
C314
C306
JW401
R10
D304
D705
JW74
Q491
C354
C356
D2
R491
C2
C9
C7
R710
D302
D704
D702
D491
IC351
JW123
JW75
C505
R301
D606
D605
C701
D301
C318
JW136
R13
JW1
JC300
JC304
JC305
C309
L901
C308
JC49
C901
D706
D703
C313
R354
C317
JC307
R5
C315
L902
C421
R363
C355
JC90
C3
C360
JW132
JC1
R4
JC306
JW45
C453
C351
JW107
C361
R445
C357
C352
JW130
JW135
R441
R444
E
R446
C358
JC93
JC102
JW101
R352
R365
C366
R361
D701
JW102
C359
C371
C362
JC504
R353
R356
R421
R451
C451
C367
Q352
C433
R433
C365
C372
C441
R452
R611
JW122
C902
JW110
C310
R431
R442
D
R357
R355
JW125
C454
D707
JW108
C431
Q452
CN410
C303
R453
R449
R359
R450
JC400
C369
JW112
JW111
Q432
R423
C434
JW113
C312
C424
R358
JW104
JW103
C423
JW92
TU1
C320
C302
R443
C8
IC300
Q420
C443
JC404
J
F901
C444
JC301
Q440
JC401
G
C301
C304
C422
C442
D352
C
C6
R12
CN300
JC302
JW126
R360
C368
F
C307
Q351
B
R448
C413
R447
C432
C452
C414
CNJ400
R606
R607
Ref. No.
D2
D101
D102
D103
D106
D301
D302
D303
D304
D305
D306
D307
D308
D309
D310
D311
D312
D352
D353
D354
D491
D494
D495
D501
D602
D603
D604
D605
D606
D607
D609
D610
D701
Location
F-2
J-3
J-2
J-3
J-3
D-8
D-8
D-9
D-9
D-6
D-6
D-6
D-6
D-6
D-6
D-7
D-7
B-2
G-8
G-8
F-6
F-8
G-8
I-5
F-10
F-11
I-10
C-10
C-10
D-10
H-9
H-9
C-8
Ref. No.
D702
D703
D704
D705
D706
D707
D901
Location
E-9
C-9
C-9
D-9
C-9
C-8
B-10
IC300
IC351
IC501
IC600
IC601
IC602
B-6
F-4
E-7
H-6
I-10
H-8
Q3
Q101
Q351
Q352
Q420
Q432
Q440
Q452
Q491
Q492
Q501
Q600
Q601
Q605
Q701
Q702
Q703
F-2
H-4
B-2
D-2
C-4
C-4
C-4
C-4
F-6
F-7
H-7
H-10
G-10
F-10
G-8
H-8
E-9
CDX-F5700/F5700X/FW570
3-14. PRINTED WIRING BOARD — SUB SECTION — • Refer to page 21 for Circuit Boards Location.
1
2
3
4
5
: Uses unleaded solder.
6
(Page 30)
A
LED802
CN801
D801
LED801
B
R801
S801
C
(Page 28)
CN802
D
E
F
3-15. SCHEMATIC DIAGRAM — SUB SECTION —
CN802
R801
CN801
LED801
D801
(Page 27)
S801
LED802
(Page 31)
29
29
CDX-F5700/F5700X/FW570
3-16. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 21 for Circuit Boards Location.
2
1
3
4
5
6
: Uses unleaded solder.
7
8
9
10
11
12
13
14
A
S9
19
02
S9
S918
IC971
LE
LED934
S903
S901
LED902
LED904
LED906
LED905
S904
LED903
S905
LED907
14
S9
S906
S907
LED908
12
S9
S913
S908
LED909
D
S909
LED910
S910
MENU
ENTER
R956
Q901
Ref. No.
D901
D902
D911
D912
D913
D914
D915
Location
G-6
G-11
G-11
H-11
G-11
H-11
G-11
IC901
IC971
G-8
B-6
LED901
LED902
LED903
LED904
LED905
LED906
LED907
LED908
C-14
D-13
D-12
D-12
D-11
D-10
D-9
D-8
R938
Location
D-7
D-6
D-5
D-3
C-2
B-2
B-3
B-5
C-5
D-4
Ref. No.
LED919
LED920
LED921
LED922
LED931
LED932
LED933
LED934
Location
C-3
B-3
B-4
B-5
B-13
C-13
B-6
C-6
Q901
H-3
Ref. No.
Q902
Q903
Q904
Q905
Q906
Q907
Q908
30
Location
H-2
H-3
H-3
G-3
G-2
G-3
G-2
30
R966
R936
CN901
D912
D914
R968
R969
R967
R971
Ref. No.
LED909
LED910
LED911
LED912
LED913
LED914
LED915
LED916
LED917
LED918
D902
R942
D915
R931
R940
R909
R929
Location
G-6
R937 R932
R907
C971
Ref. No.
IC981
R934
R908
• Semiconductor Location
I
R933
R939
R946
R945
R928
FMB4
1
D913
FMB3
90
R976
D911
C972
R904
C903
IC
R965
R972
R974
R948
Q904
R975
R901
C901
C905
C902
R903
C904
D901
R943
R902
R905
R983
R953
R944
Q903
R958
R973
R954
R912
R911
R906
Q905
R957
R977
R992
R949
R955
R947
Q902
IC981
R952
S921
Q907
R959
R926
Q906
R927
H
R950
R951
Q908
C982
G
R990
R988
R922
C983
R981
R921
R935
R923
R915
R913
C906
R924
R914
R916
R918
R984
C973
F
R917
R919
R920
R982
(Page 29)
E
LED901
C981
S920
11
LE
12
D9
D9
LED918
S911
R993
LE
LE
D9
D9
R925
17
19
LED913
R986
S915
C
LCD901
R989
R985
LED914
S916
LED931
R930
R987
R994
LE
LE
R991
D9
D9
22
20
LED921
LED932
S917
LED933
LE
16
D9
D9
15
LE
B
R941
CDX-F5700/F5700X/FW570
3-17. SCHEMATIC DIAGRAM — DISPLAY SECTION —
R971
R976
R975
R974
R973
R977
IC971
R981
R983
R985
R987
R989
R991
IC981
LED932
LED931
LED904
R993
R986
LED933
LED934
C973
R994
C971
C972
R950
R952
R954
R949
R953
R948
R947
R951
R944
R946
R943
R942
R941
R945
R938
R940
R937
R939
R936
R935
C906
LED915
LED920
R906
LED918
ENTER
LED914
LED907
LED921
R955
LED910
R982
LED919
LED901
C901 C902
R904
C905
R956
Q905
R901
R902
R903
C904
C903
R907
MODE
LED906
IC901
D902
LED911
R905
D901
LED902
R932
LED917
MENU
LED908
R934
LED912
R931
LED903
R933
LED916
R984
LED913
LED922
R908
R909
Q903
Q902
LED909
C982
DSPL
Q904
LED905
R988
R990
R992
Q901
C983
C981
R957
R958
R959
Q908
CN901
Q907
Q906
S911
R972
S901
R921
R911
S912
ENTER
S902
R912
S903
R913
R922
R965
D915
R923
(Page 29)
R967
R966
S921
R924
R968
R969
D914
D913
D912
S914
S904
R914
S905
R915
S906
R916
LCD901
R925
D911
S913
MENU
S915
R926
S916
S907
R917
R927
S917
S908
R918
R928
S918
S909
R919
DSPL
R929
S919
S910
MODE
R930
S920
31
31
R920
CDX-F5700/F5700X/FW570
3-18. IC BLOCK DIAGRAMS
IC7 R1114N151D-TR-FA (SERVO Board (2/2))
IC1 LA6560-TE-L-E (SERVO Board (2/2))
FWD 1
36 S-GND
THERMAL SHUTDOWN
VDD 1
5 VOUT
INPUT
REV 2
35 VCONT
VCC2 3
OUTPUT
CONTROL
VLO- 4
BTL-AMP
OUTPUT
ON/OFF
MUTE
34 MUTE
GND 2
33 VIN4
VLO+ 5
LEVEL
SHIFT
VO4+ 6
CURRENT
LIMIT
VREF
32 VIN4-
31 VIN4+
CE 3
VO4- 7
4 NC
30 VREF-IN
LEVEL
SHIFT
VO3+ 8
VO3- 9
VIN1/VREF-SW
IC300 TDA8588AJ/N2 (MAIN Board (1/2))
29 VIN1-SW
28 VREF-OUT
TAB 1
2 SDA
OUT-FL– 3
GND
I2C BUS
GND
4 SCL
FL
OUT-FL+ 5
6 VP2
OUT-RL– 7
27 REG-OUT
LEVEL
SHIFT
VO2+ 10
RL
8 PGND1
OUT-RL+ 9
VO2- 11
S-GND 13
25 VIN3+
LEVEL
SHIFT
VO1+ 12
10 SVR
MUTE
IN-RL 11
PROTECTION/
DIAGNOSTIC
IN-RR 15
12 IN-FL
14 IN-FR
MUTE
26 REG-IN
24 VIN3-
RR
23 VIN3
VO1- 13
16 BEEP
VP
OUT-RR+ 17
18 PGND3
OUT-RR– 19
22 VIN2+
VCC1 14
20 VP1
OUT-FR+ 21
VIN1 15
21 VIN2-
FR
OUT-FR– 23
AMP-A
L
24 PGND4
BATTERY
DETECTION
DIAG 25
VIN1+A 17
22 STB
CHIP DETECT/
DIAGNOSTIC
20 VIN2
VIN1-A 16
STANDBY/
MUTE
TEMPERATURE
PROTECTION
H
ENABLE
LOGIC
26 RST
ANT-REM 27
SWITCH
AMP-REM 29
SWITCH
VIN1-B 18
28 CRES
AMP-B
19 VIN1+B
REGULATOR
30 AUDIO+B
SERVO3.3V 31
MECH6V 33
32 GND
34 PANEL+B
VP 35
REFERENCE
VOLTAGE
BU+B 37
32
32
REGULATOR
36 CBU
LOADDUMP
PROTECTION
BACK-UP
SWITCH
CDX-F5700/F5700X/FW570
NC
ACOUTR
ACINSW
ACOUTSW
ACOUTL
ACINL
VREFOUT
VDD
AC2INL
AC2OUTL
FILOL
OUTLF
OUTLR
33
32
31
30 29
28 27 26
25
24 23
HIGH PASS
FILTER2
MIXER
NC
ACINR
IC351 TDA7416 (MAIN Board (1/2))
SOFT STEP
FADER
34
35
36
37
SOFT STEP
FADER
HIGH PASS
FILTER
SUB
WOOFER
FILTER
MIXER
22 OUTRF
SOFT STEP
FADER
21 OUTRR
7 BAND
EQUALIXER
SOFT STEP
FADER
MAIN
VOLUME
HIGH
PASS
FILTER2
SOFT STEP
FADER
SOFT
MUTE
20 AC2INR
19 AC2OUTR
18 FILOR
17 OUTSW
16 SAOUT
15 MUTE
ZERO
CROSS
LOUDNESS
SPECTRUM
ANALIZER
14 SACLK
IN-GAIN
FADER
INPUT
MULTIPLEXER
6 7
13 SCL
12 SDA
8
9 10 11
NC
GND
NC
1 2 3 4 5
II2CBUS
POWER
SUPPLY
MIX
40
41
42
43
44
REAR
SELECTOR
NC
IN1R+
IN4L
IN4R
IN3L
IN3R
IN2L
MAIN
SOURCE
SELECTOR
NC
NC
IN2R
IN1L+
IN1–
CREF 38
NC 39
IC601 BA8271F-E2
(MAIN Board (2/2))
BUS ON 1
BUS ON
SWITCH
RST 2
RESET
SWITCH
BATT 3
BATTERY
SWITCH
14 VCC
13
12
11
10
RESET
BUS ON
CLK IN
BU IN
CLK 4
VREF 5
DATA 6
9 DATA IN
GND 7
8 DATA OUT
33
CDX-F5700/F5700X/FW570
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this
parts list.
• Abbreviation
CND : Canadian model
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. MAIN SECTION
not supplied
A
MG-611MA-186//Q
#2
12
#1
#1
B
A
11
F901
10
#3
not supplied
9
13
8
7
#1
TU1
not supplied
not supplied
B
6
3
#1
4
1
#1
4
4
Ref. No.
2
5
Part No.
Description
1
2
3
4
5
X-3384-259-1
1-792-195-11
3-246-441-01
3-042-244-01
3-260-247-01
LOCK ASSY
CABLE, FLEXIBLE FLAT (14 CORE)
BUTTON (EJECT)
SCREW (T)
CUSHION (SUB PANEL)
6
7
8
9
9
X-3384-364-1
X-3384-203-1
3-713-786-51
A-3283-483-A
A-3283-563-A
PANEL ASSY, SUB
GEAR ASSY
SCREW +P 2X3
MAIN BOARD, COMPLETE (F5700/FW570)
MAIN BOARD, COMPLETE (F5700X)
34
Remark
Ref. No.
10
11
12
not supplied
(SUB board)
Part No.
Description
Remark
13
F901
3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT
1-776-207-72 CORD (WITH CONNECTOR) (POWER)
1-790-355-54 CORD (WITH CONNECTOR) (RCA)
(SUB OUT (MONO))
3-246-481-01 PLATE (TU), GROUND
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
TU1
#1
#2
#3
A-3220-959-A
7-685-792-09
7-685-790-01
7-685-793-09
TUNER UNIT (TUX-032//Q)
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X4 (S)
SCREW +PTT 2.6X8 (S)
CDX-F5700/F5700X/FW570
4-2. FRONT PANEL SECTION
#4
58
56
#4
57
55
LCD901
not
supplied
not supplied
(DISPLAY board)
54
51
not
supplied
not
supplied
not
supplied
53
52
not supplied
not supplied
Ref. No.
Part No.
Description
Remark
51
51
52
53
53
X-3384-425-2
X-3384-430-2
X-3384-637-1
X-3384-424-2
X-3384-428-2
BUTTON KIT (SVX) ASSY (F5700/FW570)
BUTTON KIT (SVX) ASSY (F5700X)
KNOB VOL (SVX) ASSY
PANEL ASSY (SVX), FRONT (F5700)
PANEL ASSY (SVX), FRONT (FW570)
53
54
55
X-3384-429-2 PANEL ASSY (SVX), FRONT (F5700X)
1-780-097-11 CONDUCTIVE BOARD, CONNECTION
X-3384-502-2 PLATE SUB ASSY (P), LIGHT GUIDE
Ref. No.
56
57
58
58
58
Part No.
Description
X-3384-284-1
X-3378-390-3
A-3220-956-A
A-3220-970-A
A-3220-971-A
PANEL ASSY (SVX), FRONT BACK
CASE (PANEL) (for FRONT PANEL)
FP-CDX-F5700//C (U) (F5700)
FP-CDX-F5700X//C (E) (F5700X)
FP-CDX-FW570//C (U) (FW570)
Remark
LCD901 1-805-458-11 DISPLAY PANEL, LIQUID CRYSTAL
#4
7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT
35
CDX-F5700/F5700X/FW570
4-3. CD MECHANISM SECTION (1)
(MG-611MA-186//Q)
102
not supplied
(SENSOR board)
101
109
#5
110
not supplied
not supplied
103
104
106
105
108
107
Ref. No.
Part No.
Description
101
102
103
104
105
A-3372-444-A
3-253-729-11
3-257-892-11
3-257-892-01
3-253-695-11
CHASSIS (T) SUB ASSY
SPRING (LTR), TENSION COIL
SPRING (DAMPER), COIL
SPRING (DAMPER), COIL
SPRING (KF), TENSION COIL
106
3-259-033-01 DAMPER (S)
36
Remark
Ref. No.
107
108
109
110
#5
Part No.
Description
3-352-758-31
A-3283-357-A
X-3384-088-1
X-3384-089-1
7-627-552-87
SCREW (M1.7), TOOTHED LOCK
SERVO BOARD, COMPLETE
LEVER (L) ASSY
LEVER (R) ASSY
SCREW, PRECISION +P 1.7X2.2
Remark
CDX-F5700/F5700X/FW570
4-4. CD MECHANISM SECTION (2)
(MG-611MA-186//Q)
155
156
157
154
(including M901)
#6
M902
SW4
158
not supplied
not supplied
not supplied
153
not supplied
151
152
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
151
152
0 153
154
155
A-3372-445-A
3-316-938-91
8-820-207-02
A-3372-448-A
A-3372-449-A
CHASSIS (OP) COMPLETE ASSY
SCREW (B1.4X5), TAPPING
OPTICAL PICK-UP (KSS1000E/K1RP)
CHASSIS (OP) SUB ASSY (including M901)
ARM SUB ASSY, CHUCKING
156
Remark
Ref. No.
157
158
M902
SW4
#6
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Part No.
Description
X-3384-090-2
3-264-165-12
A-3372-447-A
1-571-099-11
7-627-850-77
LEVER (SL) ASSY
SCREW
MOTOR ASSY, SL (SLED)
SWITCH (1 KEY) (LIMIT)
SCREW, PRECISION +P 1.4X1.8
Remark
A-3372-446-A LEVER (SL) SUB ASSY
37
CDX-F5700/F5700X/FW570
4-5. CD MECHANISM SECTION (3)
(MG-611MA-186//Q)
203
201
202
207
211
204
209
208
210
205
207
207
M903
#5
206
Ref. No.
Part No.
Description
201
202
203
204
205
3-348-993-01
3-259-024-01
A-3372-441-A
3-259-455-11
3-253-713-11
WASHER
WHEEL (RA), WORM
ARM ASSY, ROLLER
SPRING (RAL)
SPRING (RAR)
206
207
3-259-469-11 SPRING (LE), LEAF
2-134-636-21 SCREW (M1.7X2.5)
38
Remark
Ref. No.
Part No.
Description
208
209
210
211
M903
3-259-467-11
3-345-648-91
A-3372-450-A
3-259-468-11
A-3372-443-A
BRACKET (LEM)
SCREW (M1.4), TOOTHED LOCK
WORM (LEB) ASSY
BEARING (LEB)
MOTOR ASSY, LE (LOADING)
#5
7-627-552-87 SCREW, PRECISION +P 1.7X2.2
Remark
CDX-F5700/F5700X/FW570
4-6. CD MECHANISM SECTION (4)
(MG-611MA-186//Q)
254
252
255
252
256
251
253
257
Ref. No.
251
252
253
254
Part No.
Description
3-259-429-11
3-344-223-01
3-259-470-11
3-253-755-12
WHEEL (LE), WORM
WASHER
GEAR (LE1)
LEVER (D)
Remark
Ref. No.
255
256
257
Part No.
Description
Remark
3-899-829-01 WASHER (SLIT)
3-259-032-01 GEAR (LE2)
A-3337-998-A CHASSIS (M) BLOCK ASSY
39
CDX-F5700/F5700X/FW570
SECTION 5
ELECTRICAL PARTS LIST
DISPLAY
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
• Abbreviation
CND : Canadian model
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
DISPLAY BOARD
**************
X-3384-502-2 PLATE SUB ASSY (P), LIGHT GUIDE
1-780-097-11 CONDUCTIVE BOARD, CONNECTION
< CAPACITOR >
C901
C902
C903
C904
C905
1-107-826-11
1-107-826-11
1-162-964-11
1-164-227-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.001uF
0.022uF
0.22uF
10%
10%
10%
10%
10%
16V
16V
50V
25V
10V
C906
C971
C972
C973
C981
1-165-908-11
1-135-834-11
1-165-908-11
1-135-834-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
2.2uF
1uF
2.2uF
0.01uF
10%
10%
10V
6.3V
10V
6.3V
25V
C982
C983
1-162-970-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
0.01uF
0.01uF
10%
10%
25V
25V
10%
Ref. No.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Part No.
Description
Remark
LED904
LED905
LED906
LED907
LED908
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VT-T86 (5)
SML-310VT-T86 (4)
SML-310VT-T86 (3)
SML-310VT-T86 (2)
SML-310VT-T86 (1)
LED909
LED910
LED911
LED912
LED913
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VT-T86 (DSPL)
SML-310VT-T86 (MODE)
SML-310VT-T86 (ENTER)
SML-310VT-T86 (MENU)
SML-310VT-T86 (EQ7)
LED914
LED915
LED916
LED917
LED918
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VT-T86 (DSO)
SML-310VT-T86 (SOURCE)
SML-310VT-T86 (LIST CAT)
SML-310VT-T86 (RING ILLUMINATION)
SML-310VT-T86 (RING ILLUMINATION)
LED919
LED920
LED921
LED922
LED931
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
6-500-312-01
LED
LED
LED
LED
LED
SML-310VT-T86 (RING ILLUMINATION)
SML-310VT-T86 (RING ILLUMINATION)
SML-310VT-T86 (RING ILLUMINATION)
SML-310VT-T86 (RING ILLUMINATION)
HL002-W11 (LCD BACK LIGHT)
< CONNECTOR >
CN901
1-817-158-11 PLUG, CONNECTOR 14P
LED932 6-500-312-01 LED HL002-W11 (LCD BACK LIGHT)
LED933 6-500-312-01 LED HL002-W11 (LCD BACK LIGHT)
LED934 6-500-312-01 LED HL002-W11 (LCD BACK LIGHT)
< DIODE >
< TRANSISTOR >
D901
D902
D911
D912
D913
8-719-988-61
8-719-069-55
8-719-083-66
8-719-069-56
8-719-069-56
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
UDZS-TE17-5.6B
UDZS-TE17-18B
UDZS-TE17-6.2B
UDZS-TE17-6.2B
D914
D915
8-719-069-56 DIODE UDZS-TE17-6.2B
8-719-069-56 DIODE UDZS-TE17-6.2B
< IC >
IC901
IC971
IC981
6-701-640-01 IC LC75813T-E
6-600-321-01 IC KSM-401Y (IR)
6-705-374-01 IC MM3033DULE
< LIQUID CRYSTAL DISPLAY >
LCD901 1-805-458-11 DISPLAY PANEL, LIQUID CRYSTAL
< DIODE >
LED901 8-719-053-09 LED SML-310VT-T86 (COLOR)
LED902 8-719-053-09 LED SML-310VT-T86 (OFF)
LED903 8-719-053-09 LED SML-310VT-T86 (6)
40
Q901
Q902
Q903
Q904
Q905
8-729-920-31
8-729-920-31
8-729-920-31
8-729-920-31
8-729-920-31
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC343TK
DTC343TK
DTC343TK
DTC343TK
DTC343TK
Q906
Q907
Q908
8-729-920-31 TRANSISTOR DTC343TK
8-729-920-31 TRANSISTOR DTC343TK
8-729-920-31 TRANSISTOR DTC343TK
< RESISTOR >
R901
R902
R903
R904
R905
1-216-821-11
1-216-821-11
1-216-821-11
1-216-840-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
39K
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R911
1-216-857-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
1K
1K
1K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
CDX-F5700/F5700X/FW570
DISPLAY
Ref. No.
Remark
Ref. No.
MAIN
Part No.
Description
Part No.
Description
R912
R913
R914
R915
R916
1-216-819-11
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
1K
1.5K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R976
R977
R981
R982
R983
1-216-809-11
1-216-803-11
1-216-805-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
33
47
47
47
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R917
R918
R919
R920
R921
1-216-825-11
1-216-827-11
1-216-829-11
1-218-867-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
4.7K
6.8K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R984
R985
R986
R987
R988
1-216-805-11
1-216-805-11
1-216-805-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
47
47
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R922
R923
R924
R925
R926
1-216-819-11
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
1K
1.5K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R989
R990
R991
R992
R993
1-216-805-11
1-216-805-11
1-216-805-11
1-216-805-11
1-216-810-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
47
47
47
120
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R927
R928
R929
R930
R931
1-216-825-11
1-216-827-11
1-216-829-11
1-218-867-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
4.7K
6.8K
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R994
1-216-810-11 METAL CHIP
120
5%
1/10W
R932
R933
R934
R935
R936
1-216-813-11
1-216-815-11
1-216-811-11
1-216-815-11
1-216-811-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
330
150
330
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R937
R938
R939
R940
R941
1-216-815-11
1-216-813-11
1-216-815-11
1-216-811-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
220
330
150
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R942
R943
R944
R945
R946
1-216-811-11
1-216-815-11
1-216-813-11
1-216-815-11
1-216-811-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
330
220
330
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R947
R948
R949
R950
R951
1-216-815-11
1-216-811-11
1-216-815-11
1-216-813-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
150
330
220
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R952
R953
R954
R955
R956
1-216-811-11
1-216-815-11
1-216-811-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
330
150
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R957
R958
R959
R965
R966
1-216-815-11
1-216-815-11
1-216-819-11
1-216-025-11
1-216-025-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
330
330
680
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R967
R968
R969
R971
R972
1-216-025-11
1-216-025-11
1-216-025-11
1-216-809-11
1-216-821-11
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100
100
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R973
R974
R975
1-216-845-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100K
100
100
5%
5%
5%
1/10W
1/10W
1/10W
< SWITCH >
S901
S902
S903
S904
S905
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (OFF)
SWITCH, TACTILE (SOURCE)
SWITCH, TACTILE (6)
SWITCH, TACTILE (5/BBE MP)
SWITCH, TACTILE (4)
S906
S907
S908
S909
S910
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (3)
SWITCH, TACTILE (2/SHUF)
SWITCH, TACTILE (1/REP)
SWITCH, TACTILE (DSPL)
SWITCH, TACTILE (MODE)
S911
S912
S913
S914
S915
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (COLOR)
SWITCH, TACTILE (ENTER)
SWITCH, TACTILE (DISC/PRESET –)
SWITCH, TACTILE (MENU)
SWITCH, TACTILE (. SEEK – m)
S916
S917
S918
S919
S920
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (EQ7)
SWITCH, TACTILE (DSO)
SWITCH, TACTILE (DISC/PRESET +)
SWITCH, TACTILE (LIST CAT)
SWITCH, TACTILE (M SEEK + >)
S921
1-478-474-11 ENCODER, ROTARY
(PUSH KNOB SOUND,VOLUME)
*************************************************************
A-3283-483-A MAIN BOARD, COMPLETE (F5700/FW570)
A-3283-563-A MAIN BOARD, COMPLETE (F5700X)
*********************
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT
7-685-793-09 SCREW +PTT 2.6X8 (S)
< CAPACITOR >
C2
C3
C4
1-126-947-11 ELECT
1-162-970-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
47uF
0.01uF
0.001uF
20%
10%
10%
C5
C6
1-126-947-11 ELECT
1-162-970-11 CERAMIC CHIP
47uF
0.01uF
20%
10%
16V
25V
50V
(F5700X)
16V
25V
C7
C8
C9
1-162-970-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
0.01uF
0.01uF
0.01uF
10%
10%
10%
25V
25V
25V
41
CDX-F5700/F5700X/FW570
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C301
C302
C303
C304
C305
1-115-340-11
1-162-970-11
1-128-551-11
1-115-340-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.01uF
22uF
0.22uF
0.01uF
10%
10%
20%
10%
10%
Remark
25V
25V
25V
25V
25V
Ref. No.
C423
C424
C431
C432
C433
1-137-194-11
1-162-927-11
1-126-964-11
1-163-251-11
1-137-194-11
FILM
CERAMIC CHIP
ELECT
CERAMIC CHIP
FILM
0.47uF
100PF
10uF
100PF
0.47uF
5%
5%
20%
5%
5%
50V
50V
50V
50V
50V
Remark
C306
C307
C308
C309
C310
1-126-964-11
1-162-970-11
1-126-964-11
1-127-715-11
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.01uF
10uF
0.22uF
10uF
20%
10%
20%
10%
20%
50V
25V
50V
16V
50V
C434
C441
C442
C443
C444
1-162-927-11
1-126-964-11
1-163-251-11
1-137-194-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
FILM
CERAMIC CHIP
100PF
10uF
100PF
0.47uF
100PF
5%
20%
5%
5%
5%
50V
50V
50V
50V
50V
C312
C313
C314
C315
C316
1-115-340-11
1-162-970-11
1-126-964-11
1-162-970-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.22uF
0.01uF
10uF
0.01uF
10uF
10%
10%
20%
10%
20%
25V
25V
50V
25V
50V
C451
C452
C453
C454
C491
1-126-964-11
1-163-251-11
1-137-194-11
1-162-927-11
1-126-947-11
ELECT
CERAMIC CHIP
FILM
CERAMIC CHIP
ELECT
10uF
100PF
0.47uF
100PF
47uF
20%
5%
5%
5%
20%
50V
50V
50V
50V
16V
C317
C318
C319
C320
C325
1-126-961-11
1-162-923-11
1-127-715-11
1-162-970-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2.2uF
47PF
0.22uF
0.01uF
0.01uF
20%
5%
10%
10%
10%
50V
50V
16V
25V
25V
C500
C501
C502
C504
C505
1-162-970-11
1-162-970-11
1-104-665-11
1-162-970-11
1-125-710-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
DOUBLE LAYERS
0.01uF
0.01uF
100uF
0.01uF
0.1F
10%
10%
20%
10%
25V
25V
10V
25V
5.5V
C329
C330
C351
C352
C353
1-162-970-11
1-162-970-11
1-126-947-11
1-162-970-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
0.01uF
47uF
0.01uF
10uF
10%
10%
20%
10%
20%
25V
25V
16V
25V
50V
C506
C507
C510
C511
C512
1-126-924-11
1-162-970-11
1-162-916-11
1-162-917-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330uF
0.01uF
12PF
15PF
0.01uF
20%
10%
5%
5%
10%
10V
25V
50V
50V
25V
C354
C355
C356
C357
C358
1-125-837-11
1-125-837-11
1-125-837-11
1-162-965-11
1-136-154-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
1uF
1uF
1uF
0.0015uF
0.012uF
10%
10%
10%
10%
5%
6.3V
6.3V
6.3V
50V
50V
C513
C514
C515
C516
C517
1-162-970-11
1-162-970-11
1-216-845-11
1-162-970-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
METAL CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100K
0.01uF
0.001uF
10%
10%
5%
10%
10%
25V
25V
1/10W
25V
50V
C359
C360
C361
C362
C363
1-136-154-00
1-162-965-11
1-125-837-11
1-125-837-11
1-126-960-11
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.012uF
0.0015uF
1uF
1uF
1uF
5%
10%
10%
10%
20%
50V
50V
6.3V
6.3V
50V
C518
C519
C521
C600
C601
1-162-964-11
1-162-964-11
1-162-964-11
1-126-935-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
470uF
0.01uF
10%
10%
10%
20%
10%
50V
50V
50V
16V
25V
C364
C365
C366
C367
C368
1-126-960-11
1-126-960-11
1-126-960-11
1-126-960-11
1-162-964-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
1uF
1uF
0.001uF
20%
20%
20%
20%
10%
50V
50V
50V
50V
50V
C701
C702
C703
C704
C901
1-131-868-81
1-126-961-11
1-126-963-11
1-115-340-11
1-162-964-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
3300uF
2.2uF
4.7uF
0.22uF
0.001uF
20%
20%
20%
10%
10%
16V
50V
50V
25V
50V
C369
C371
C372
C401
C402
1-162-927-11
1-126-964-11
1-162-962-11
1-128-551-11
1-162-970-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100PF
10uF
470PF
22uF
0.01uF
5%
20%
10%
20%
10%
50V
50V
50V
25V
25V
C902
C904
1-162-964-11 CERAMIC CHIP
1-162-923-11 CERAMIC CHIP
0.001uF
47PF
10%
5%
50V
50V
C403
C405
C407
C409
C412
1-128-551-11
1-128-551-11
1-128-551-11
1-126-964-11
1-162-970-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
22uF
22uF
22uF
10uF
0.01uF
20%
20%
20%
20%
10%
25V
25V
25V
50V
25V
C413
C414
C415
C416
C417
1-163-251-11
1-163-251-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.01uF
0.01uF
0.01uF
5%
5%
10%
10%
10%
50V
50V
25V
25V
25V
C420
C421
C422
1-162-964-11 CERAMIC CHIP
1-126-964-11 ELECT
1-163-251-11 CERAMIC CHIP
0.001uF
10uF
100PF
10%
20%
5%
50V
50V
50V
< CONNECTOR >
CN300
CN350
CN370
* CN410
CNJ400
1-774-701-21
1-817-536-11
1-784-456-11
1-564-506-11
1-580-907-41
PIN, CONNECTOR 16P
CONNECTOR, BOARD TO BOARD 28P
CONNECTOR, FFC/FPC 14P
PLUG, CONNECTOR 3P
PLUG, CONNECTOR (BUS CONTROL IN)
< DIODE >
42
D2
D101
D102
D103
D106
8-719-069-55
6-500-886-01
6-500-886-01
8-719-978-33
8-719-083-66
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE17-5.6B
RSA6.1ENTR
RSA6.1ENTR
DTZ-TT11-6.8B
UDZS-TE17-18B
D301
D302
8-719-200-82 DIODE 11ES2
8-719-200-82 DIODE 11ES2
CDX-F5700/F5700X/FW570
MAIN
Ref. No.
Part No.
Description
Part No.
Description
D303
D304
D305
D306
D307
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
Remark
JC102
JC103
JC104
JC105
JC108
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
0
D308
D309
D310
D311
D312
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
JC109
JC110
JC300
JC301
JC302
1-216-296-11
1-216-864-11
1-216-296-11
1-216-296-11
1-216-864-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
0
D352
D353
D354
D491
D494
8-719-978-33
8-719-058-24
8-719-058-24
8-719-404-50
8-719-058-24
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
RB501V-40TE-17
RB501V-40TE-17
MA111-TX
RB501V-40TE-17
JC304
JC305
JC306
JC307
JC400
1-216-296-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-296-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
0
0
0
0
D495
D501
D602
D603
D604
8-719-058-24
8-719-820-05
8-719-083-66
8-719-056-84
8-719-083-66
DIODE
DIODE
DIODE
DIODE
DIODE
RB501V-40TE-17
1SS181
UDZS-TE17-18B
UDZ-TE-17-7.5B
UDZS-TE17-18B
JC401
JC404
JC408
JC501
JC502
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
D605
D606
D607
D609
D610
8-719-083-66
8-719-072-70
8-719-049-38
8-719-058-24
8-719-058-24
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE17-18B
MA2ZD14001S0
1N5404TU
RB501V-40TE-17
RB501V-40TE-17
JC503
JC504
JC505
JC506
JC507
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
D701
D702
D703
D704
D705
8-719-083-66
8-719-083-66
8-719-978-33
8-719-083-66
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE17-18B
UDZS-TE17-18B
DTZ-TT11-6.8B
UDZS-TE17-18B
MA111-TX
JC508
JC509
JC510
JC512
JC601
1-216-296-11
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
D706
D707
D901
8-719-083-66 DIODE UDZS-TE17-18B
8-719-083-66 DIODE UDZS-TE17-18B
8-719-083-66 DIODE UDZS-TE17-18B
JC604
JC605
JC608
JC702
JC703
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC704
1-216-296-11 SHORT CHIP
0
< IC >
IC300
IC351
IC501
IC600
IC601
6-705-359-01
6-703-303-01
6-705-373-01
6-803-741-01
6-703-884-01
IC
IC
IC
IC
IC
TDA8588AJ/N2
TDA7416
MM3123DPLE
MN101E01KDG
BA8271F-E2
IC602
8-759-659-13 IC PST3428UL
Remark
5%
1/10W
5%
1/10W
5%
1/10W
5%
5%
1/10W
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
5%
1/10W
1/10W
5%
1/10W
5%
5%
1/10W
1/10W
5%
1/10W
< FERRITE BEAD >
< JACK >
J1
J370
J451
Ref. No.
1-815-185-13 JACK (ANTENNA)
1-566-822-41 JACK (REMOTE IN)
1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,
AUDIO OUT REAR,AUDIO OUT FRONT)
L4
L100
L300
L301
L302
1-469-562-21
1-216-864-11
1-456-617-11
1-216-864-11
1-216-864-11
FERRITE, EMI (SMD)
METAL CHIP
0
COIL, CHOKE
250uH
METAL CHIP
0
METAL CHIP
0
L303
L401
L402
L403
L404
1-216-864-11
1-469-876-11
1-500-245-11
1-500-245-11
1-500-245-11
METAL CHIP
0
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
L405
L406
L407
L408
L409
1-469-876-11
1-500-245-11
1-469-876-11
1-216-864-11
1-216-864-11
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
METAL CHIP
0
METAL CHIP
0
L410
L501
L901
L902
1-469-876-11
1-216-864-11
1-469-844-11
1-216-864-11
INDUCTOR, FERRITE BEAD
METAL CHIP
0
INDUCTOR
2.2uH
METAL CHIP
0
< JUMPER RESISTOR >
JC1
JC16
JC17
JC49
JC51
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC52
JC90
JC93
JC101
1-216-296-11
1-216-864-11
1-216-296-11
1-216-296-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
(F5700/FW570)
5%
1/10W
5%
1/10W
(F5700/FW570)
43
CDX-F5700/F5700X/FW570
MAIN
Ref. No.
L902
Part No.
Description
Remark
1-469-844-11 INDUCTOR
2.2uH (F5700X)
< TRANSISTOR >
Q3
Q101
Q351
Q352
Q420
8-729-106-68
8-729-047-76
6-550-683-01
6-550-752-01
6-550-752-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1615A-GP
FMC2A-T148
RJK005N03-T146
DTC614TKT146
DTC614TKT146
Q432
Q440
Q452
Q491
Q492
6-550-752-01
6-550-752-01
6-550-752-01
8-729-027-23
1-801-806-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC614TKT146
DTC614TKT146
DTC614TKT146
DTA114EKA-T146
DTC144EKA (F5700/FW570)
Q492
Q501
Q600
Q601
Q605
8-729-027-43
8-729-027-23
8-729-047-76
8-729-027-23
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146 (F5700X)
DTA114EKA-T146
FMC2A-T148
DTA114EKA-T146
DTC114EKA-T146
Q701
Q702
Q703
8-729-120-28 TRANSISTOR 2SC1623-L5L6
8-729-120-28 TRANSISTOR 2SC1623-L5L6
8-729-120-28 TRANSISTOR 2SC1623-L5L6
< RESISTOR >
Ref. No.
Part No.
Description
R360
R361
R362
R363
R364
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R365
Remark
100
100
100
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-793-11 METAL CHIP
4.7
5%
R365
1-216-864-11 METAL CHIP
0
R370
R371
R401
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-864-11 METAL CHIP
100
100
0
1/10W
(F5700X)
5%
1/10W
(F5700/FW570)
5%
1/10W
5%
1/10W
5%
1/10W
R402
R421
R423
R431
R433
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R441
R442
R443
R444
R445
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R446
R447
R448
R449
R450
1-216-809-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R451
R452
R453
R491
R500
1-216-809-11
1-216-841-11
1-216-809-11
1-216-805-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
100
47
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R501
R506
R507
R508
R509
1-216-821-11
1-216-813-11
1-216-864-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
0
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R510
R511
R512
R513
R514
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R516
1-216-845-11 METAL CHIP
100K
5%
R4
R5
R6
R7
R10
1-216-839-11
1-216-843-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
68K
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R12
R13
R101
R102
R103
1-216-864-11
1-216-864-11
1-216-821-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
1K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R104
R105
R106
R107
R108
1-216-809-11
1-216-809-11
1-216-821-11
1-216-821-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
1K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R109
R110
R111
R112
R113
1-218-871-11
1-249-417-11
1-249-417-11
1-216-864-11
1-216-864-11
METAL CHIP
CARBON
CARBON
METAL CHIP
METAL CHIP
10K
1K
1K
0
0
0.5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/10W
1/10W
R115
R116
R120
R121
R301
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R517
R518
R520
1-216-845-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
0
100K
R522
1-216-821-11 METAL CHIP
1K
1/10W
(F5700X)
5%
1/10W
5%
1/10W
5%
1/10W
(F5700/FW570)
5%
1/10W
R302
R351
R352
R353
R354
1-216-841-11
1-216-845-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R523
R524
R525
R526
R527
1-216-845-11
1-216-833-11
1-216-845-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
100K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R355
R356
R357
R358
R359
1-216-833-11
1-216-833-11
1-216-825-11
1-216-825-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
2.2K
2.2K
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R528
R529
R530
R531
R532
1-216-845-11
1-216-845-11
1-216-845-11
1-216-849-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
220K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
44
CDX-F5700/F5700X/FW570
MAIN
Ref. No.
Remark
Part No.
Description
1-216-845-11
1-218-871-11
1-216-845-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
100K
0
0
5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R538
R542
R544
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
100K
5%
5%
5%
R545
1-216-845-11 METAL CHIP
100K
5%
R546
1-216-864-11 METAL CHIP
0
5%
1/10W
1/10W
1/10W
(F5700X)
1/10W
(F5700X)
1/10W
R547
R548
R549
R560
R561
1-216-864-11
1-216-864-11
1-216-864-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
1K
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C1
C2
C3
C4
C5
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
16V
R601
R602
R603
R604
R606
1-216-849-11
1-216-849-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C6
C7
C8
C10
C11
1-162-970-11
1-162-962-11
1-162-962-11
1-104-609-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
470PF
470PF
100uF
0.1uF
10%
10%
10%
20%
10%
25V
50V
50V
4V
16V
R607
R608
R610
R611
R701
1-216-821-11
1-216-829-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C13
C14
C16
C18
C19
1-162-965-11
1-162-965-11
1-107-826-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0015uF
0.1uF
0.022uF
0.022uF
10%
10%
10%
10%
10%
50V
50V
16V
25V
25V
R702
R703
R704
R705
R706
1-216-841-11
1-216-833-11
1-216-833-11
1-249-425-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
47K
10K
10K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
C21
C22
C23
C24
C25
1-107-826-11
1-162-962-11
1-162-967-11
1-162-962-11
1-162-967-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
0.0033uF
470PF
0.0033uF
10%
10%
10%
10%
10%
16V
50V
50V
50V
50V
R707
R708
R709
R710
R711
1-216-841-11
1-216-829-11
1-216-833-11
1-249-425-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
47K
4.7K
10K
4.7K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
C26
C27
C28
C29
C30
1-162-970-11
1-126-208-21
1-107-826-11
1-164-156-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
25V
4V
16V
25V
16V
R712
1-216-837-11 METAL CHIP
22K
5%
1/10W
C32
C33
C34
C35
C36
1-164-156-11
1-164-156-11
1-107-826-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
25V
25V
16V
16V
25V
C37
C38
C39
C40
C41
1-164-677-11
1-107-826-11
1-162-927-11
1-162-969-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.033uF
0.1uF
100PF
0.0068uF
0.1uF
10%
10%
5%
10%
16V
16V
50V
25V
25V
C42
C43
C44
C45
C46
1-162-970-11
1-125-837-11
1-162-970-11
1-162-970-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
1uF
0.01uF
0.01uF
0.0015uF
10%
10%
10%
10%
10%
25V
6.3V
25V
25V
50V
C47
C48
C49
C50
C51
1-107-826-11
1-104-609-11
1-125-837-11
1-125-837-11
1-164-156-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
1uF
1uF
0.1uF
10%
20%
10%
10%
16V
4V
6.3V
6.3V
25V
C52
1-100-381-11 ELECT CHIP
10uF
20%
16V
S102
S103
S501
1-786-458-11 SWITCH, PUSH (1 KEY) (NOSE DET)
1-692-431-21 SWITCH, TACTILE (RESET)
1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT)
(F5700X)
< THERMISTOR (POSITIVE) >
TH400
Description
Remark
SENSOR BOARD
**************
< SWITCH >
SW2
1-529-566-61 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
A-3283-357-A SERVO BOARD, COMPLETE
**********************
< CAPACITOR >
1-803-350-21 THERMISTOR, POSITIVE
< TUNER >
TU1
Part No.
SERVO
R533
R534
R535
R536
R537
< SWITCH >
Ref. No.
SENSOR
A-3220-959-A TUNER UNIT (TUX-032//Q)
< VIBRATOR >
X500
1-813-160-11 VIBRATOR, CERAMIC (27.648MHz)
X501
1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
45
CDX-F5700/F5700X/FW570
SERVO
Ref. No.
Part No.
Description
C53
C54
C55
C56
C57
1-100-381-11
1-164-156-11
1-164-156-11
1-162-970-11
1-164-156-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.1uF
0.01uF
0.1uF
Part No.
Description
16V
25V
25V
25V
25V
Remark
R7
R8
R9
R10
R11
1-208-635-11
1-218-971-11
1-218-971-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10
33K
33K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C58
C59
C60
C63
C64
1-107-826-11
1-107-826-11
1-100-381-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.01uF
0.1uF
10%
10%
20%
10%
10%
16V
16V
16V
25V
16V
R12
R13
R14
R15
R16
1-208-635-11
1-218-965-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
10
10K
0
0
0
5%
5%
1/16W
1/16W
C65
C66
C67
C74
C75
1-126-208-21
1-164-156-11
1-107-826-11
1-126-208-21
1-162-970-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47uF
0.1uF
0.1uF
47uF
0.01uF
20%
10%
20%
10%
4V
25V
16V
4V
25V
R17
R18
R19
R20
R21
1-218-965-11
1-218-965-11
1-218-969-11
1-218-969-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
10K
22K
22K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
C77
C79
C81
C83
C85
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
6.3V
R22
R23
R24
R25
R26
1-218-967-11
1-218-967-11
1-218-953-11
1-218-953-11
1-218-981-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
15K
15K
1K
1K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C86
C91
C92
C107
C109
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
R27
R28
R29
R37
R38
1-218-965-11
1-218-990-11
1-218-977-11
1-218-947-11
1-218-967-11
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
0
100K
330
15K
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
C110
C115
1-107-826-11 CERAMIC CHIP
1-162-966-11 CERAMIC CHIP
0.1uF
10%
0.0022uF 10%
16V
50V
R39
R40
R41
R42
R43
1-218-941-81
1-218-990-11
1-218-985-11
1-218-965-11
1-218-977-11
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
0
470K
10K
100K
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
R44
R45
R46
R47
R48
1-218-957-11
1-218-971-11
1-218-957-11
1-218-977-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
33K
2.2K
100K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R49
R50
R52
R53
R54
1-218-953-11
1-218-941-81
1-218-941-81
1-218-959-11
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
100
100
3.3K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1-218-953-11
1-218-973-11
1-218-941-81
1-218-941-81
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
1K
47K
100
100
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
< TRANSISTOR >
R55
R56
R57
R59
R60
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
R61
R62
R64
R65
R67
1-218-985-11
1-218-965-11
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
470K
10K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R68
R69
R70
R71
R72
1-218-990-11
1-218-973-11
1-218-945-11
1-218-941-81
1-218-990-11
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
0
47K
220
100
0
5%
5%
5%
1/16W
1/16W
1/16W
R73
R74
R76
1-218-941-81 RES-CHIP
1-218-941-81 RES-CHIP
1-218-941-81 RES-CHIP
100
100
100
5%
5%
5%
1/16W
1/16W
1/16W
20%
10%
< CONNECTOR >
CN1
CN2
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-817-275-21 CONNECTOR, BOARD TO BOARD 28P
< JUMPER RESISTOR >
FB1
FB2
FB5
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
0
5%
5%
5%
1/10W
1/10W
1/10W
< IC >
IC1
IC3
IC4
IC7
IC8
Q1
Q2
Q3
Q5
Q6
6-705-366-01
8-753-216-86
6-804-028-01
6-705-364-01
6-705-365-01
8-729-904-87
8-729-928-90
8-729-904-87
8-729-904-87
8-729-928-90
IC
IC
IC
IC
IC
LA6560-TE-L-E
CXD3059BR
MB90487PFV-G-105-BNDE1
R1114N151D-TR-FA
TC94A34FG-002
2SB1197K-R
DTC114EE
2SB1197K-R
2SB1197K-R
DTC114EE
< RESISTOR >
R1
R2
R3
R4
R5
1-218-941-81
1-218-971-11
1-218-971-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
33K
33K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R6
1-218-965-11 RES-CHIP
10K
5%
1/16W
46
Ref. No.
Remark
CDX-F5700/F5700X/FW570
SERVO
Ref. No.
Part No.
Description
R77
R78
R79
R80
R81
1-218-990-11
1-218-941-81
1-218-941-81
1-218-977-11
1-218-941-81
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
100
100
100K
100
Remark
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R85
R86
R87
R91
R92
1-218-973-11
1-218-973-11
1-218-973-11
1-220-200-81
1-218-971-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
47K
47K
30K
33K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R97
R98
R99
R101
R106
1-218-941-81
1-218-941-81
1-218-965-11
1-218-969-11
1-218-969-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
10K
22K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R107
R108
R109
R110
R111
1-218-965-11
1-218-941-81
1-218-953-11
1-218-945-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
100
1K
220
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R114
R115
R116
R117
R119
1-218-941-81
1-218-941-81
1-218-941-81
1-218-990-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
100
100
100
0
100
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R122
R123
R124
R126
R127
1-218-965-11
1-218-990-11
1-216-864-11
1-218-965-11
1-218-965-11
RES-CHIP
SHORT CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
0
0
10K
10K
5%
1/16W
5%
5%
5%
1/10W
1/16W
1/16W
R128
R129
R133
R136
R139
1-218-965-11
1-218-965-11
1-216-864-11
1-218-977-11
1-218-957-11
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
10K
0
100K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R140
R141
R142
R143
R144
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R145
R146
R147
R148
R149
1-218-977-11
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
SUB
Remark
SUB BOARD
**********
1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE) (CN802)
< CONNECTOR >
CN801
< DIODE >
D801
8-719-056-83 DIODE UDZ-TE-17-6.8B
LED801 8-719-082-38 LED CL-270SR-C-TS (DOOR IND)
LED802 6-500-450-01 LED CL-195SR-CD-T (Z)
< RESISTOR >
R801
< SWITCH >
SW1
1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN)
< VIBRATOR >
X1
1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz)
X2
1-795-822-21 VIBRATOR, CERAMIC (18.43MHz)
*************************************************************
1-817-159-11 SOCKET, CONNECTOR 14P
1-216-817-11 METAL CHIP
470
5%
1/10W
< SWITCH >
S801
1-771-884-31 SWITCH, TACTILE (Z)
*************************************************************
MISCELLANEOUS
***************
11
12
0 153
154
F901
1-776-207-72 CORD (WITH CONNECTOR) (POWER)
1-790-355-54 CORD (WITH CONNECTOR) (RCA)
(SUB OUT (MONO))
8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP)
A-3372-448-A CHASSIS (OP) SUB ASSY (including M901)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3372-447-A MOTOR ASSY, SL (SLED)
M903
A-3372-443-A MOTOR ASSY, LE (LOADING)
SW4
1-571-099-11 SWITCH (1 KEY) (LIMIT)
*************************************************************
ACCESSORIES
************
1-476-526-14 REMOTE COMMANDER (RM-X114)
3-230-047-01 LID, BATTERY CASE (for RM-X114)
3-262-850-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
(F5700)
3-262-850-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH)
(FW570)
3-262-851-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH) (F5700)
3-262-851-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH) (FW570)
3-263-708-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
TRADITIONAL CHINESE)
(F5700X)
3-263-709-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,TRADITIONAL CHINESE)
(F5700X)
X-3378-390-3 CASE (PANEL) (for FRONT PANEL)
*************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
47
CDX-F5700/F5700X/FW570
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
301
302
303
304
305
X-3382-647-1
X-3381-154-1
3-349-410-11
3-934-325-01
3-261-758-01
306
307
3-246-471-01 KEY (FRAME)
1-776-207-72 CORD (WITH CONNECTOR) (POWER)
301
FRAME ASSY, FITTING
SCREW ASSY (BS4), FITTING (F5700X)
BUSHING (F5700X)
SCREW, +K (5X8) TAPPING (F5700/FW570)
COLLAR
302
303
304
48
305
306
307
CDX-F5700/F5700X/FW570
MEMO
49
CDX-F5700/F5700X/FW570
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.
Ver.
1.0
50
Date
2004. 02
Description of Revision
New
www.s-manuals.com