Download Single Revolving Oven
Transcript
Single Revolving Oven MODEL SR, SR-2, SRW, SRC, KS & LMWS Service Manual CS-TM-029.01 Revised 3/27/13 BKI LIMITED WARRANTY 2812 Grandview Dr. • Simpsonville, SC 29680 • USA (864) 963-3471 • Toll Free: (800) 927-6887 • Fax: (864) 963-5316 WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: The equipment has not been accidentally or intentionally damaged, altered or misused; The equipment is properly installed, adjusted, operated and maintained in accordance with national and local codes, and in accordance with the installation and operating instructions provided with this product. The serial number rating plate affixed to the equipment has not been defaced or removed. WHO IS COVERED This warranty is extended to the original purchaser and applies only to equipment purchased for use in the U.S.A. COVERAGE PERIOD Warranty claims must be received in writing by BKI within one (1) year from date of installation or within one (1) year and three (3) months from data of shipment from the factory, whichever comes first. COB Models: One (1) Year limited parts and labor. COM Models: Two (2) Year limited parts and labor. COM convection ovens also have a two (2) year door warranty. CO1 Models: Two (2) Year limited parts and labor. Five (5) Year limited door warranty. BevLes Products: Two (2) Year limited parts and labor. Warranty period begins the date of dealer invoice to customer or ninety (90) days after shipment date from BKI, whichever comes first. WARRANTY COVERAGE This warranty covers on-site labor, parts and reasonable travel time and travel expenses of the authorized service representative up to (100) miles round trip and (2) hours travel time and performed during regular, weekday business hours. EXCEPTIONS Any exceptions must be pre-approved in advance and in writing by BKI. The extended door warranty on convection ovens years 3 through 5 is a parts only warranty and does not include labor, travel, mileage or any other charges. EXCLUSIONS Negligence or acts of God, Thermostat calibrations after (30) days from equipment installation date, Air and gas adjustments, Light bulbs, Glass doors and door adjustments, Fuses, Adjustments to burner flames and cleaning of pilot burners, Tightening of screws or fasteners, Failures caused by erratic voltages or gas suppliers, Unauthorized repair by anyone other than a BKI Factory Authorized Service Center, Damage in shipment, Alteration, misuse or improper installation, Thermostats and safety valves with broken capillary tubes, Freight – other than normal UPS charges, Ordinary wear and tear, Failure to follow installation and/or operating instructions, Events beyond control of the company. INSTALLATION Leveling, as well as proper installation and check out of all new equipment per appropriate installation and use materials – is the responsibility of the dealer or installer, not the manufacturer. REPLACEMENT PARTS BKI genuine Factory OEM parts receive a (90) day materials warranty effective from the date of installation by a BKI Factory Authorized Service Center. CS-TM-029.01 Revised 3/27/13 Single Revolving Oven Table of Contents Table of Contents Table of Contents..................................................................................................................................................... 1 Introduction .............................................................................................................................................................. 2 Safety Precautions................................................................................................................................................. 2 Safety Signs and Messages.............................................................................................................................. 2 Safe Work Practices.......................................................................................................................................... 3 Health And Sanitation Practices ............................................................................................................................ 5 Food Handling ................................................................................................................................................... 5 Storage Of Raw Meats ...................................................................................................................................... 5 Coding Cooked Foods....................................................................................................................................... 5 Storage Of Prepared Foods .............................................................................................................................. 5 Maintenance ............................................................................................................................................................. 6 Scheduled Maintenance ........................................................................................................................................ 6 Oven Cleaning................................................................................................................................................... 6 Troubleshooting ..................................................................................................................................................... 7 Replacement Parts................................................................................................................................................... 8 SR Parts List.......................................................................................................................................................... 8 KS Parts List ........................................................................................................................................................ 16 SR-2 Parts List..................................................................................................................................................... 20 SRC Parts List ..................................................................................................................................................... 26 SRW Parts List .................................................................................................................................................... 32 LMWS Parts List .................................................................................................................................................. 35 Accessories ......................................................................................................................................................... 37 Wiring Diagrams..................................................................................................................................................... 38 1 Single Revolving Oven Introduction Introduction The units covered in this manual are single revolving rotisserie ovens containing tubular heating elements, manual electronic controls, quarts tube lamps and doors with tempered glass. The BKI name and trademark on this unit assures you of the finest in design and engineering -- that it has been built with care and dedication -- using the best materials available. Attention to the operating instructions regarding proper installation, operation, and maintenance will result in long lasting dependability to ensure the highest profitable return on your investment. PLEASE READ THIS ENTIRE MANUAL BEFORE OPERATING THE UNIT. If you have any questions, please contact your BKI Distributor. If they are unable to answer your questions, contact the BKI Technical Service Department, toll free: 1-800-927-6887. Outside the U.S., call 1-864-963-3471. Safety Precautions Always follow recommended safety precautions listed in this manual. Below is the safety alert symbol. When you see this symbol on your equipment, be alert to the potential for personal injury or property damage. Safety Signs and Messages The following Safety signs and messages are placed in this manual to provide instructions and identify specific areas where potential hazards exist and special precautions should be taken. Know and understand the meaning of these instructions, signs, and messages. Damage to the equipment, death or serious injury to you or other persons may result if these messages are not followed. This message indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. This message indicates a potentially hazardous situation, which, if not avoided, could result in death or serious injury. This message indicates a potentially hazardous situation, which, if not avoided, may result in minor or moderate injury. It may also be used to alert against unsafe practices. This message is used when special information, instructions or identification are required relating to procedures, equipment, tools, capacities and other special data. 2 Single Revolving Oven Introduction Safe Work Practices Wear Safe Clothing Appropriate To Your Job Always wear your insulated mitts when handling hot racks or touch any hot metal surface. If you lose or damage your mitts, you can buy new ones at your local restaurant equipment supply store or from your local BKI Distributor. Always wear non-skid shoes when working around the oven or any other equipment. Never wear loose clothing such as neckties or scarves while operating this equipment. Keep loose hair tied back or in a hair net while operating this equipment. Always wear appropriate personal protection equipment during the cleaning process to guard against possible injury from hot cleaning solution. Beware of High Voltage This equipment uses high voltage. Serious injury can occur if you or any untrained or unauthorized person installs, services, or repairs this equipment. Always Use an Authorized Service agent to Service Your Equipment. Keep this manual with the Equipment This manual is an important part of your equipment. Always keep it near for easy access. If you need to replace this manual, contact: BKI Technical Services Department 2812 Grandview Drive Simpsonville, S.C. 29680 Or call toll free: 1-800-927-6887 Outside the U.S., call 864-963-3471 Protect Children Keep children away from this equipment. Children may not understand that this equipment is dangerous for them and others. NEVER allow children to play near or operate your equipment. Keep Safety Labels Clean and in Good Condition Do not remove or cover any safety labels on your equipment. Keep all safety labels clean and in good condition. Replace any damaged or missing safety labels. If you need a new safety label contact: BKI Technical Services Department 2812 Grandview Drive Simpsonville, S.C. 29680 Or call toll free: 1-800-927-6887 Outside the U.S., call 864-963-3471 3 Single Revolving Oven Introduction Be Prepared for Emergencies Be prepared for fires, injuries, or other emergencies. Keep a first aid kit and a fire extinguisher near the equipment. You must use a 40pound Type BC fire extinguisher and keep it within 25 feet of your equipment. Keep emergency numbers for doctors, ambulance services, hospitals, and the fire department near your telephone. Know your responsibilities as an Employer • Make certain your employees know how to operate the equipment. • Make certain your employees are aware of the safety precautions on the equipment and in this manual. • Make certain that you have thoroughly trained your employees about operating the equipment safely. • Make certain the equipment is in proper working condition. If you make unauthorized modifications to the equipment, you will reduce the function and safety of the equipment. 4 Single Revolving Oven Introduction Health And Sanitation Practices BKI Rotisserie Ovens are manufactured to comply with health regulations and are tested and certified to NSF standards. You must operate the equipment properly, using only quality products and use meat thermometers to insure meats are thoroughly cooked. Food Handling • Wash hands thoroughly in warm, soapy water after handling raw poultry or meats. • Clean and sanitize all utensils and surfaces that have been in contact with raw products. Clean and sanitize the meat forks or baskets between cooking. • Never place cooked meats on the same surfaces used to prepare raw meats, unless the area has been thoroughly cleaned and sanitized. Storage Of Raw Meats • Designate an area or shelf strictly for the storage of all raw meats to be used in the rotisserie. • Raw product must always be stored at temperatures below 38° F. (3° C.). • Never store or mix raw foods above cooked foods, as this is a health hazard. The drippings from raw foods contaminate cooked or processed foods. • All chicken and chicken parts to be stored overnight must be thoroughly iced down and refrigerated. Coding Cooked Foods All products cooked during the day should be sold the same day. NOTE: It is not the intent of the rotisserie program to have unsold merchandise at the end of the cooking day. Follow your company’s procedures for the handling of any leftover product. Storage Of Prepared Foods • Cold foods should be kept at or below 38° F. (3° C.). • Hot foods must be maintained to meet local health codes, usually a minimum 145° F. (63° C.). 5 Single Revolving Oven Maintenance Maintenance Failure to comply with the maintenance below could result in a serious accident or equipment damage. Failure to remove power from this unit before performing maintenance may cause severe electrical shock. This unit may have more than one disconnect switch. Scheduled Maintenance Oven Cleaning The oven must be cleaned at the end of each business day. Cleaning is not only necessary for sanitary reasons, but will increase sales appeal and maximize operating efficiency. Failure to remove power from this unit may cause severe electrical shock. This unit may have more than one disconnect switch. Using abrasive cleaners may damage the cabinet finish. Use only a mild soap and water solution. DO NOT USE OVEN CLEANER on this machine. Caustic cleaners can cause damage to the machine. Never steam clean or get excess water in the interior of the cabinet as this can damage unit. Always wear appropriate personal protection equipment during the cleaning process to guard against possible injury from hot cleaning solution. 1. Turn off all switches and controls. 2. Let the oven cool to room temperature. 3. Pull grease drawer out of oven and empty it’s contents. 4. Clean grease drawer and tray area with hot soapy water. 5. Remove all food products from the unit. Remove all racks, trays, spits and frames from the unit and place them in a large sink to soak in hot cleaning solution (BKI Cleaner). 6. Clean the outside and inside of the rotisserie oven with warm water, a sponge and an approved cleaner which is authorized for use on food surface areas. 7. Clean racks, trays, spits and frames with warm water, a sponge and BK Cleaner. Wipe dry with a clean cloth. 8. Reassemble the oven. 6 Single Revolving Oven Maintenance Troubleshooting Problem Cause Possible Solution Unit will not turn on. Power to unit is not on. Problem with building power panel, circuit breaker or fuse. Check circuit breaker or fuses at building power panel. If problem persists, contact an authorized electrician for corrective action. Plug cord into outlet. Power cord may not be plugged into outlet. Blown fuse. Not rotating. Motor circuit breaker tripped. ROTOR switch may not be activated. V-belt is loose or broken. Rotor switch not functioning. Defective switch. Oven does not heat at all. Improper program settings. Heating elements not functioning. Bad relay. Oven heats up slowly. Doors may not be closed. Improper line voltage. Heating elements not functioning. 7 Contact an authorized BKI service agent for corrective action. Press the reset button. If problem persists, contact an authorized BKI service agent for corrective action. Make sure the ROTOR switch is on. Contact an authorized BKI service agent for corrective action. Contact an authorized BKI service agent for corrective action. Check program settings. Contact an authorized BKI service agent for corrective action. Contact an authorized BKI service agent for corrective action. Close the doors. Check incoming voltage. If problem persists, contact an authorized BKI service agent for corrective action. Contact an authorized BKI service agent for corrective action. Single Revolving Oven Replacement Parts Replacement Parts Use the information in this section to identify replacement parts. To order replacement parts, call your local BKI sales and service representative. Before calling, please note the serial number on the rating tag affixed to the unit. SR Parts List Figure 1. SR Oven 8 Single Revolving Oven Replacement Parts Table 1. SR Oven Parts ITEM # 1 2 PART # B0452B C0001 or C0004 or C0002 SB0045 AN10100100 QTY 2 2 2 1 DESCRIPTION CALROD BRACKET ASSY, SR CALROD, 208V 2500W OFFSET or CALROD, 208V 2500W STRAIGHT or CALROD, 240V 2500W OFFSET CATCH SPRING SUBASSY CTL PNL SR 120/208/60/3 N0 H/S 5 6 7 8 9 10 11 12 13 14 15 16 17 18 SB0049 SB0005 SB0218 SB0085 SB0222 G0022 LMWSA019 KSA039 H0001 SRA061 H0061 LH0003 L0004 1 1 2 2 1 2 2 2 2 2 1 4 1 1 DOOR ASSY, LH SR DOOR ASSY, RH SR DROP DOWN PNL ASSY S/S SR DROP DOWN PNL LESS CATCH S/S GREASE DRAWER ASSY, S/S SR'S GUARD, GRILL 6 BAR (BOTTOM) GUARD, QUARTZ TUBE (1000W) GUARD, QUARTZ TUBE (500W) HINGE, DOOR 7/8 OFFSET HEAT LOC STRIP, 7 7/8" HINGE, DRP DN OLF SS PIN 1267A LAMPHOLDER, QUARTZ TUBE LATCH, #533D MOTOR MOUNT 19 20 21 22 SRA033 SRA076 HT0016 HT0002 or HT0003 2 1 1 1 MOTOR COVER SR OUTSIDE TOP, QUARTZ TUBE, 115-125V QH500T3 QUARTZ TUBE, 200-220V QH1000T3 or QUARTZ TUBE, 230-250V QH1000T3 ROTOR ASSEMBLY 3 4 23 1 24 25 SB0007 SB0111 2 1 26 27 SRWA026 VB0005 1 1 SIDE STIFFENER ASSY SR TOP OUTSIDE FRAME WELD ASSY KS TOP STIFFNER SRW V-BELT, 4L-740 9 FIGURE # Figure 1 Figure 1 TABLE # Table 1 Table 1 Figure 1 Figure 1 Figure 2 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 Figure 3 Figure 1 Figure 1 Figure 1 Figure 1 Table 1 Table 1 Table 2 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 1 Table 3 Table 1 Table 1 Table 1 Table 1 Figure 1 Figure 4 Figure 1 Figure 1 Table 1 Table 4 Table 1 Table 1 Figure 1 Figure 1 Table 1 Table 1 Single Revolving Oven Replacement Parts Figure 2. SR Control Panel 10 Single Revolving Oven Replacement Parts Table 2. SR Control Panel Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 PART # B1050 CB0050 F0097 FH0001 K0028 N0232 P0084 R0001 S0103 S0107 K0033 SRA089 T0005 TI0009 SRA047 QTY 1 1 1 1 1 1 1 1 1 3 1 1 1 1 1 DESCRIPTION BEZEL, ROBERTSHAW THERMOSTAT BREAKER, CIRCUIT 3 AMP 250V FUSE, 15A 300V SC15 TIME DELAY FUSE HOLDER, 15A 300V HPF-EE KNOB, T-STAT BLK 450DEG DECAL, CONTROL PANEL SR PLUG, DUMMY 5X2-71-XX BL MATTE RELAY, 4 POLE 110/120V SWITCH, RKR DPST 15A 250V LAMP SWITCH, RKR SPST 15A 125V LAMP KNOB, 3 HR TIMER TI0009 INSPECTION PLATE CONTROL PANEL THERMOSTAT, 115-277V 450 DEG SGLPOLE TIMER, 3 HR PANEL, CONTROL SR 11 Single Revolving Oven Replacement Parts Figure 3. SR Motor Mount 12 Single Revolving Oven Replacement Parts Table 3. SR Motor Mount Parts ITEM # 1 2 3 4 5 PART # SB0034 M0064 H0019 SR2A037 P0017 SB0025 QTY 1 1 1 1 1 1 DESCRIPTION MOTOR MTG ASSY, 115V SR LMWS MOTOR, 42R3BFSI-5L 115V 50/60 HINGE, 3 1/8" BUTT MOTOR MOUNT PLATE, BB, LMWS PULLEY, AS 20 X 5/8 MTG PLATE & SCREW WELD, SR 13 Single Revolving Oven Replacement Parts Figure 4. SR Rotor Assembly 14 Single Revolving Oven Replacement Parts Table 4. SR Rotor Assembly Parts ITEM # PART # a&b 1 SCR384 2 SRA058 3 B0204 4 H0081 5 F0077 6 AN10504800 7 AN10513900 a 8 RO0036 b 9 RO0023 10 FT0031 11 WN10504600 12 H0082 a&b 13 P0085 a&b 14 WSH101 a - Part of AN10513900. b - Part of AN10504800 QTY 12 4 4 2 2 1 1 1 1 1 1 2 6 12 DESCRIPTION SCREW, 5/16-18 X 1/2 S/S HEX BEARING BLOCK 5/8 SHAFT BEARING, TZ002591 HUB, SR KNOCK OFF SPIDER TYPE ROLL PIN, 5/32 X 1 1/8 ROTOR ASSY, “V” SIDE ROTOR ASSY, PIN SIDE ROTOR, PIN SIDE SR MSR (AN10513900) ROTOR, POINT SIDE MODULAR UNIT (AN10504800) COLLAR, 5/8 SET LSC-10 SHAFT/PULLEY WELD SPINNER, SR KNOCK OFF HUB PIN, STAND OFF 1.125" WASHER, 5/16 INT LOCK 15 Single Revolving Oven Replacement Parts KS Parts List Figure 5. KS Oven 16 Single Revolving Oven Replacement Parts Table 5. KS Oven Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 PART # KSA110 SB0111 SRWA026 SB0112 HT0016 or HT0002 or HT0003 HCA014 KSA035 H0001 SB0608 S0023B S0034 C0001 or C0002 B0452B G0022 KSA080 SB0602 or SB0683 SB0627 or SB0684 L0004 SB0678 or SB0601 KSA009 SB0221 AN60000100 or AN60000200 or AN60000300 or SB0644 SB0620 KSA099 C0406 S0024 SB0607 KSA033 B0212 KSA027 R0001 R0002 KSA098 B0451 QTY 2 1 1 1 1 4 2 2 2 4 2 2 2 2 2 1 1 1 1 or 2 1 1 1 1 1 4 1 1 1 1 1 1 1 1 1 DESCRIPTION TOP INSIDE PANEL, S/S TOP OUTSIDE FRAME WELD ASSY KS TOP STIFFNER SRW TOP, OUTSIDE W/STAND OFF ROD QUARTZ TUBE, 115-125V QH500T3 or QUARTZ TUBE, 200-220V QH1000T3 or QUARTZ TUBE, 230-250V QH1000T3 GUARD, LAMPHOLDER PLATE SR KS LMWS MOTOR COVER, KS HINGE, DOOR 7/8 OFFSET CHAIN ASSY, KS 13 LINK SPROCKET, KS PTFE COATED SEAL, RULON "A" BUSHING CALROD, 208V 2500W OFFSET or CALROD, 240V 2500W OFFSET CALROD BRACKET ASSY, SR GUARD, GRILL 6 BAR (BOTTOM) HEAT LOC STRIP DOOR ASSY RH KS L0004 LATCH or DOOR ASSY RH KS L0103 LATCHKET DOOR ASSY LH KS L0004 LATCH or DOOR ASSY LH KS L0103 LATCH LATCH, #533D DROP DOWN PANEL ASSY S/S or DROP DOWN PNL S/S KS DRAWER, GREASE, FRONT GREASE DRAWER WELD, S/S SR CTL PNL KS 120/208/60/3 NO H/S&G/S or CTL PNL KS 220/380/50/3 NO H/S&G/S or CTL PNL KS 220/60/3 or CTL PNL KS 220/60/3 MOTOR MOUNT ASSY, KS SHAFT 1 X 38.062 W/KEYWAY KS CASTER, W/TOP PLATE 5" SPROCKET, DRIVE 50B70 LOWER BEARING ADJ. WELD, KS BRACKET, UPPER BEARING, KS BEARING, FAFNIR VCJT-1 SIDE STIFFENER KS RELAY, 4 POLE 110/120V RELAY, 2 POLE 110/120V SHAFT 1 X 35.625 KS TOP BRACKET, KS CTR CALROD 17 FIGURE # Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 TABLE # Table 5 Table 5 Table 5 Table 5 Table 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Figure 5 Figure 5 Figure 5 Figure 5 Table 5 Table 5 Table 5 Table 5 Figure 5 Table 5 Figure 5 Figure 5 Table 5 Table 5 Figure 5 Figure 5 Figure 5 Figure 6 Table 5 Table 5 Table 5 Table 6 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Table 5 Single Revolving Oven ITEM # 35 36 37 38 39 40 PART # C0004 or C0005 LH0021 SPCA062 SPC309 SB0625 SB0626 41 SB0612 Replacement Parts QTY 2 2 2 2 1 1 1 DESCRIPTION CALROD, 208V 2500W STRAIGHT or CALROD, 240V 2500W STRAIGHT LAMPHOLDER, #62602 HI TEMP TUBING, KS TOP STAND OFF BRACKET, STAND OFF SR MICRO SWITCH BRKT ASSY KS (operator side) MICRO SWITCH BRKT ASSY KS (customer side) COVER, CALROD ASSY, KS Figure 6. KS Control Panel 18 FIGURE # Figure 5 TABLE # Table 5 Figure 5 Figure 5 Figure 5 Figure 5 Figure 5 Table 5 Table 5 Table 5 Table 5 Table 5 Figure 5 Table 5 Single Revolving Oven Replacement Parts Table 6. KS Control Panel Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 PART # S0103 B1050 K0028 or K0025 S0107 P0084 F0097 FH0001 CB0050 N0235 KSA021 T0005 or T0001 TI0009 or TI0018 QTY 1 1 1 4 2 1 1 1 1 1 1 1 DESCRIPTION SWITCH, RKR DPST 15A 250V LAMP BEZEL, ROBERTSHAW THERMOSTAT KNOB, T-STAT BLK 450DEG or KNOB, T-STAT 450 DEG FLAT@12 SWITCH, RKR SPST 15A 125V LAMP PLUG, DUMMY 5X2-71-XX BL MATTE FUSE, 15A 300V SC15 TIME DELAY FUSE HOLDER, 15A 300V HPF-EE BREAKER, CIRCUIT 3 AMP 250V DECAL, CONTROL PANEL KS PANEL, CONTROL KS THERMOSTAT, 115-277V 450 DEG SGLPOLE or THERMOSTAT, 450 DEG 208V TIMER, 3 HR or TIMER, 180 MIN 115V 50HZ 19 FIGURE # Figure 6 Figure 6 Figure 6 TABLE # Table 6 Table 6 Table 6 Figure 6 Figure 6 Figure 6 Figure 6 Figure 6 Figure 6 Figure 6 Figure 6 Table 6 Table 6 Table 6 Table 6 Table 6 Table 6 Table 6 Table 6 Figure 6 Table 6 Single Revolving Oven Replacement Parts SR-2 Parts List Figure 7. SR-2 Oven (Sheet 1 of 2) 20 Single Revolving Oven Replacement Parts Figure 7. SR-2 Oven (Sheet 2 of 2) 21 Single Revolving Oven Replacement Parts Table 7. SR-2 Oven Parts ITEM # 1 2 3 4 5 6 7 PART # SPCA062 SPC309 HT0002 or HT0003 LMWSA019 R0001 or R0003 or R0150 SR2A035 8 9 10 11 VB0006 C0415 SB0107 12 AN11100100 or AN11100200 or AN11100300 or AN11100400 L0004 G0022 H0061 SB0045 SB0085 or SB0218 SRA061 SB0005 and SB0049 H0061 B0452B SB0126 C0001 or C0002 KSA039 HT0016 G0023 LH0003 SB0112 VB0005 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 QTY 1 2 2 4 2 2 4 1 1 1 2 4 8 4 8 2 and 2 8 4 1 4 4 2 2 4 1 1 DESCRIPTION TUBING, KS TOP STAND OFF BRACKET, STAND OFF SR QUARTZ TUBE, 200-220V QH1000T3 or QUARTZ TUBE, 230-250V QH1000T3 GUARD, QUARTZ TUBE (1000W) RELAY, 4 POLE 110/120V or RELAY, 4 POLE 240V or RELAY, 4 POLE 208-240 60 HZ MOTOR COVER SR2 MOTOR MOUNT V-BELT, A-135D CASTER, 3"SWIVEL W/BREAK GREASE DRAWER ASSY, BTM SR2 ROTOR ASSEMBLY CTL PNL SR2 120/208-240/1-3 NO H/S or CTL PNL SR2 208-240 NO H/S or CTL PNL SR2 220/380/50/3 NO H/S or CTL PNL SR2 120/240/50/1 NO H/S LATCH, #533D GUARD, GRILL 6 BAR (BOTTOM) HINGE, DRP DN OLF SS PIN 1267A CATCH SPRING SUBASSY DROP DOWN PNL LESS CATCH S/S or DROP DOWN PNL ASSY S/S SR HEAT LOC STRIP, 7 7/8" DOOR ASSY, RH SR and DOOR ASSY, LH SR HINGE, DRP DN OLF SS PIN 1267A CALROD BRACKET ASSY, SR SIDE GREASE DRAWER ASSY, SR'S CALROD, 208V 2500W OFFSET or CALROD, 240V 2500W OFFSET GUARD, QUARTZ TUBE (500W) QUARTZ TUBE, 115-125V QH500T3 GUARD, GRILL 9 BAR (TOP) LAMPHOLDER, QUARTZ TUBE TOP, OUTSIDE W/STAND OFF ROD V-BELT, 4L-740 22 FIGURE # Figure 7 Figure 7 Figure 7 TABLE # Table 7 Table 7 Table 7 Figure 7 Figure 7 Table 7 Table 7 Figure 7 Figure 7 Figure 8 Figure 7 Figure 7 Figure 7 Figure 7 Figure 4 Figure 7 Figure 9 Table 7 Table 7 Table 8 Table 7 Table 7 Table 7 Table 7 Table 4 Table 7 Table 9 Figure 7 Figure 7 Figure 7 Figure 7 Figure 7 Table 7 Table 7 Table 7 Table 7 Table 7 Figure 7 Figure 7 Table 7 Table 7 Figure 7 Figure 7 Figure 7 Figure 7 Table 7 Table 7 Table 7 Table 7 Figure 7 Figure 7 Figure 7 Figure 7 Figure 7 Figure 7 Table 7 Table 7 Table 7 Table 7 Table 7 Table 7 Single Revolving Oven Replacement Parts Figure 8. SR-2 Motor Mount Table 8. SR-2 Motor Mount Parts ITEM # 1 2 3 4 5 PART # M0033 or M0064 H0019 SR2A037 P0017 SB0026 QTY 2 2 2 2 4 DESCRIPTION MOTOR, 208/230V 50/60 CYCLE or MOTOR, 42R3BFSI-5L 115V 50/60 HINGE, 3 1/8" BUTT MOTOR MOUNT PLATE, BB, LMWS PULLEY, AS 20 X 5/8 MTG PLATE & SCREW WELD, SR-2 23 Single Revolving Oven Replacement Parts Figure 9. SR-2 Control Panel 24 Single Revolving Oven Replacement Parts Table 9. SR-2 Control Panel Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 PART # TI0009 or TI0018 T0001 or T0005 CB0050 or CB0058 SR2A010 N0232 and N0422 P0084 S0107 F0097 FH0001 B1050 K0025 or K0028 S0103 QTY 2 2 2 1 1 2 6 2 2 2 2 2 DESCRIPTION TIMER, 3 HR or TIMER, 180 MIN 115V 50HZ THERMOSTAT, 450 DEG 208V or THERMOSTAT, 115-277V 450 DEG SGLPOLE BREAKER, CIRCUIT 3 AMP 250V or BREAKER, CIRCUIT 1 AMP 250V CTL PNL SR2 DECAL, CONTROL PANEL SR and DECAL, CONTROL PANEL BOTT SR2 PLUG, DUMMY 5X2-71-XX BL MATTE SWITCH, RKR SPST 15A 125V LAMP FUSE, 15A 300V SC15 TIME DELAY FUSE HOLDER, 15A 300V HPF-EE BEZEL, ROBERTSHAW THERMOSTAT KNOB, T-STAT 450 DEG FLAT@12 or KNOB, T-STAT BLK 450DEG SWITCH, RKR DPST 15A 250V LAMP 25 Single Revolving Oven Replacement Parts SRC Parts List Figure 10. SRC Oven (Sheet 1 of 2) 26 Single Revolving Oven Replacement Parts Figure 10. SRC Oven (Sheet 2 of 2) 27 Single Revolving Oven Replacement Parts Table 10. SRC Oven Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 PART # SPCA062 SPC309 HT0016 LH0003 KSA039 SRCA083 F0099 SRCA037 SRCA036 M0032 B0204 SRA058 C0406 or C0415 R0001 or R0003 SRCA063 AN30100100 or SB0338 or AN30100300 or SB0342 or AN30100200 SB0045 G0023 SB0301 SB0312 or SB0341 H0001 SB0003 or SB0218 or SB0085 SB0343 or SB0625 SB0126 C0001 or C0002 B0452B SB0049 SRA061 SR2A035 QTY 1 2 1 4 2 1 1 1 1 1 2 2 4 2 2 1 2 1 1 1 8 2 1 1 2 2 2 8 2 DESCRIPTION TUBING, KS TOP STAND OFF BRACKET, STAND OFF SR QUARTZ TUBE, 115-125V QH500T3 LAMPHOLDER, QUARTZ TUBE GUARD, QUARTZ TUBE (500W) INSIDE TOP, S/S ROTOR ASSEMBLY FAN, 9" TORIN AIROTOR SRC COVER, BLOWER MOTOR TOP, BLOWER COVER SRC MOTOR, HOWELL FAN 115/230 BEARING, TZ002591 BEARING BLOCK 5/8 SHAFT CASTER, W/TOP PLATE 5" or CASTER, 3"SWIVEL W/BREAK RELAY, 4 POLE 110/120V or RELAY, 4 POLE 240V RELAY PLATE, SRC CTL PNL SRC 120/208-240/3 NO H/S or CTL PNL SRC 220/380/50/3 or CTL PNL SRC 220/380/50/3 NO H/S or CTL PNL SRC STR 240V 3PH or CTL PNL SRC STR 240V 3PH NO H/S CATCH SPRING SUBASSY GUARD, GRILL 9 BAR (TOP) DOOR ASSY, RH BOTTOM SRC DOOR ASSY, LH BOTT SRC or DOOR ASSY, LH BOTT SRC HINGE, DOOR 7/8 OFFSET DROP DOWN PNL ASSY PORC SR or DROP DOWN PNL ASSY S/S SR or DROP DOWN PNL LESS CATCH S/S MICRO SWITCH BRKT ASSY SRC or MICRO SWITCH BRKT ASSY KS SIDE GREASE DRAWER ASSY, SR'S CALROD, 208V 2500W OFFSET or CALROD, 240V 2500W OFFSET CALROD BRACKET ASSY, SR DOOR ASSY, LH SR HEAT LOC STRIP, 7 7/8" MOTOR COVER SR2 28 FIGURE # Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 4 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 TABLE # Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 4 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Figure 10 Table 10 Figure 10 Figure 10 Figure 11 Table 10 Table 10 Table 11 Figure 10 Figure 10 Figure 10 Figure 10 Table 10 Table 10 Table 10 Table 10 Figure 10 Figure 10 Table 10 Table 10 Figure 10 Table 10 Figure 10 Figure 10 Table 10 Table 10 Figure 10 Figure 10 Figure 10 Figure 10 Table 10 Table 10 Table 10 Table 10 Single Revolving Oven ITEM # 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 PART # HT0002 or HT0003 LMWSA019 SRWA026 SB0111 SB0112 SRCA066 SRCA031 SRCA026 SRCP038B SB0305B SRCP027B SR1003 R0029 SRCA041 SRCA057 H0211 NUT187 SCR257 SRCA086 SB0340 SB0332 SB0333 SP0004 SB0304 SB0120 or SB0034 VB0006 B0066 or B0553 LH0001 SRCA034 SRCA032 Replacement Parts QTY 1 4 1 1 1 1 1 1 1 2 1 2 5 1 1 1 2 2 1 1 1 1 12 2 1 1 4 4 4 1 DESCRIPTION QUARTZ TUBE, 200-220V QH1000T3 or QUARTZ TUBE, 230-250V QH1000T3 GUARD, QUARTZ TUBE (1000W) TOP STIFFNER SRW TOP OUTSIDE FRAME WELD ASSY KS TOP, OUTSIDE W/STAND OFF ROD CALROD ACCESS PANEL RS CUST PANEL, OUTSIDE MOTOR SRC CALROD ACCESS PANEL LS CUST CABINET, PORC INSIDE BLOWER SIDE INSERT ASSY, ELEC NKL SRC CONVECTION INSIDE TOP, PORC. RACK, SIDE TRAY SRC RACK, 19 1/4 X 25 3/4 STOP, BOTTOM DOOR SRC BRACKET, BOTTOM DOOR HANDLE HANDLE, SRC DOOR, 8.5X1 NUT, CAP 1/4-20 NC 1/2" HEAD SCREW, 1/4-20 X 1/2 PHIL FLT INSIDE BLOWER CABINET, SRC CALROD PIGTAIL ASSY SRC 220/380 CALROD PIGTAIL ASSY SRC120/208 CALROD PIGTAIL ASSY SRC120/240 SPACER, ALUM 3/4 X 1 1/2 CALROD COVER WELD ASSY, SRC MOTOR MOUNT ASSY 240V or MOTOR MTG ASSY, 115V SR LMWS V-BELT, A-135D BULB, 40A15 130V PTFE COATED or BULB, TUFFSKIN 40W 250V LAMPHOLDER, RD PORCELAIN BRACKET, LIGHT SOCKET SRC PANEL, REAR INSIDE BLWR MTG 29 FIGURE # Figure 10 TABLE # Table 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Figure 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Table 10 Figure 10 Figure 10 Table 10 Table 10 Figure 10 Figure 10 Figure 10 Table 10 Table 10 Table 10 Single Revolving Oven Replacement Parts Figure 11. SRC Control Panel 30 Single Revolving Oven Replacement Parts Table 11. SRC Control Panel Parts ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 PART # S0103 B1050 K0028 S0107 P0084 FH0001 F0097 FH0003 F0104 SRCA048 N0234 CB0050 T0005 TI0018 or TI0009 N0232 QTY 1 2 2 6 1 1 1 1 1 1 1 1 2 2 1 DESCRIPTION SWITCH, RKR DPST 15A 250V LAMP BEZEL, ROBERTSHAW THERMOSTAT KNOB, T-STAT BLK 450DEG SWITCH, RKR SPST 15A 125V LAMP PLUG, DUMMY 5X2-71-XX BL MATTE FUSE HOLDER, 15A 300V HPF-EE FUSE, 15A 300V SC15 TIME DELAY FUSE HOLDER, 20A 300V HPS-JJ FUSE, 20A 300V SC20 TIME DELAY PANEL, CONTROL SRC DECAL, CONTROL PANEL SRC LOGO BREAKER, CIRCUIT 3 AMP 250V THERMOSTAT, 115-277V 450 DEG SGLPOLE TIMER, 180 MIN 115V 50HZ or TIMER, 3 HR DECAL, CONTROL PANEL SR 31 Single Revolving Oven Replacement Parts SRW Parts List SRW Part # SB0237 SB0217 SB0233 SR2A056 SPCA162 B0453 B0066 B0553 SR2A051 F0158 F0155 SB0290A SB0292A SB0296A B0452B SRWA131 C0221 C0001 C0222 C0002 F0063 FT0031 SB0289 SRWA077 SRWA008 AN20100100 SB0295 SB0293 AN20100200 N0202 N0166 N0409 N0022 N0444 N0363 N0034 SB0210 SB0049 SB0202 SB0005 SB0218 SB0085 FT0255 SRW Part Description BASE ASSY 208 240V SRW CASTERS BASE ASSY SRW 115V CASTERS BOTTOM RACK ASSY, SRW BRACE, MOTOR COVER SR2 BRACKET, CALROD MTG CANADA BRACKET, SRW CALROD BULB, 40A15 130V PTFE COATED BULB, TUFFSKIN 40W 250V BUMPER, KS BUSHING, BLK 1/2 HEYCO SNAP BUSHING, BLK 7/8 HEYCO SNAP CAB ASSY SRW S/S NO CAM CAB ASSY SRW SOL BACK NO CAM CAB ASSY SRW SOL BACK NO CAM CALROD BRACKET ASSY, SR CALROD GROUNDING CLIP, CANADA CALROD, 208V 2000W CALROD, 208V 2500W OFFSET CALROD, 240V 2000W CALROD, 240V 2500W OFFSET CLAMP, SAFETY 16101-S 1/4 DIA COLLAR, 5/8 SET LSC-10 CORD SET, 7' ALBERTSON SRW MSR CORNER POST SRW COVER, MOTOR SRW CTL PNL SRW 120/208/60/1-3 NO H/S CTL PNL SRW 220/380/60/1-3 CTL PNL SRW 220/60/1 CTL PNL SRW 240/60/3 NO H/S DECAL, DANGER HIGH VOLTAGE DECAL, DO NOT USE HARSH CLEANERS DECAL, LOGO LARGE DIE CAST DECAL, NSF DECAL, NSF TREATED LAMP NOTICE DECAL, REMOVABLE ROTORS DECAL, WATER PAN NOTICE DOOR ASSY, LH BOTT SRW DOOR ASSY, LH SR DOOR ASSY, RH BOTT SRW DOOR ASSY, RH SR DROP DOWN PNL ASSY S/S SR DROP DOWN PNL LESS CATCH S/S ELL, 3/4 90 DEG 32 Single Revolving Oven SRW Part # SRWA058 SRWA059 KSA071 SB0222 G0022 HCA014 SRA053 H0081 SRWA073 SRA089 SRWA087 G0052 I0011 I0002 I0010 LH0021 LH0001 SRA056 SRWA039 SRWA098 SRA108 N0023 NUT076 NUT083 NUT082 SRWA072 SRA076 SRWA038 SRA046 SRWA124 SRA052 FT0015 HT0016 HT0002 HT0003 R0022 RC0009 RIV170 F0024 F0025 F0015 F0077 SB0011B AN10513900 AN10504800 Replacement Parts SRW Part Description FLANGE, FLEXIBLE TUBING FLEX HOSE STRAP GASKET, GREASE SMOKER GREASE DRAWER ASSY, S/S SR'S GUARD, GRILL 6 BAR (BOTTOM) GUARD, LAMPHOLDER PLATE SR KS LMWS HINGE BLOCK, KS, SP, DP HUB, SR KNOCK OFF SPIDER TYPE INSIDE H/S COVER PLATE INSPECTION PLATE CONTROL PANEL INSUL PANEL, WARMER W/LIGHTS INSULATED MITT 13" INSULATION, KAOWOOL STRIP INSULATION, PEERLESS FIBER 3" INSULATION, RANGE 1" FIBERGLASS LAMPHOLDER, #62602 HI TEMP LAMPHOLDER, RD PORCELAIN LATCH BLOCK, KS LID, SMALL LOUVER SRW LIGHT GUARD, SRW MOTOR COVER SPACER, SR SERIES NAME & RATING TAG, UL NUT, 10-24 PALNUTS NUT, SPEED PS-312010-S NUT, SPEED PS-438014-S OUTSIDE H/S COVER PLATE OUTSIDE TOP, PANEL, MDL LOUVERED SRW PANEL, SIDE INSL SR PANEL, TOP INSULATION PLATE, OUTSIDE CALROD KS SR SERIES PLUG, HOLE 1/2" QUARTZ TUBE, 115-125V QH500T3 QUARTZ TUBE, 200-220V QH1000T3 QUARTZ TUBE, 230-250V QH1000T3 RACK, 24 1/2 X 26 RECEPTACLE, FLUSH 60A 250V RIVET, 1/8 ALUM (.063-.125) RIVNUT, #10-24 RIVNUT, 5/16"-18 ROLL PIN, 5/32 X 1 1/4 ROLL PIN, 5/32 X 1 1/8 ROTOR ASSY 6 TRAY LHW/SPRINGS ROTOR ASSY MSR ROTOR ASSY, W/O SPRINGS 33 Single Revolving Oven SRW Part # SRWA067 SCR244 SCR369 SCR136 SCR356 SCR118 SCR006 SCR448 SCR067 WN10504600 SB0206 KSA096 SB0219 SP0007 H0082 SB0209 SRA091 SB0008 SB0008A F0294 F0081 SB0111 SRWA026 SB0112 TF0035 VB0009 F0126 WSH252 WSRWA079 SB0203 SB0239 Replacement Parts SRW Part Description S/S SLIDE FOR RACK SCREW, 10-24 X 1/2 SLTD TRUSS SCREW, 10-24 X 3/4 PHIL RD SCREW, 10-24 X 3/8 SLTD TRUSS SCREW, 5/16-18 X 5/16 SOC SET SCREW, 6-32 X 5/8 SLTD RD SCREW, 8 X 1/2 PHIL PAN SCREW, STUD 10-24 X 1-1/4 WELD SCREW,5/16-18 X 2 1/2 SLTD TRUSS SHAFT/PULLEY WELD MSR SR SR2 SRW SIDE STIFFENER ASSY SRW SKIRT, BOTTOM SOLID PANEL, S/S SR SPACER, ALUM 11/16" SPINNER, SR KNOCK OFF HUB SRW S/S SOLID DOOR PNL, BOTTOM STAND OFF STRIP TERM BLOCK ASSY, 4 TB0001 TERM BRKT ASSY 1 0R 3P TERMINAL, RING TONGUE THREAD INSERT 3/8-16 STEEL TOP OUTSIDE FRAME WELD ASSY KS TOP STIFFNER SRW TOP, OUTSIDE W/STAND OFF ROD TRANSFORMER, 230V 50/60HZ TO V-BELT, A-120 WASHER, REDUCER #125-75 APP WASHER, PTFE SR SERIES WATER PAN WELDMENT, SRW WELL ASSY, SRW 120/208 WELL ASSY, SRW 208 OR 240V 34 Single Revolving Oven Replacement Parts LMWS Parts List LMWS Part # SB5318 SB5325 SB5308 SPCA162 SR2A043 B0066 B0553 F0156 SB5331 SRWA131 C0215 C0216 F0063 FT0049 LMWSA022 AN53000300 AN53000500 AN53000400 AN53000200 AN53000600 N0387 N0517 N0202 N0409 N0022 N0444 N0363 N0034 SB5319 SB5307 SRWA059 KSA071 SB5304 HCA014 H0101 H0100 SRWA073 SRA089 G0052 I0011 I0002 I0010 I0005 LMWS Part Description BASE ASSY, CASTERS LMWS 115V BASE ASSY, CASTERS LMWS 220V BLOWER MOTOR ASSY, LMWS BRACKET, CALROD MTG CANADA BRACKET, GREASE DRAWER SR2 BULB, 40A15 130V PTFE COATED BULB, TUFFSKIN 40W 250V BUSHING, BLK 5/8 HEYCO SNAP CAB ASSY LMWS S/S CALROD GROUNDING CLIP, CANADA CALROD, 208V 1100W CALROD, 240V 1100W CLAMP, SAFETY 16101-S 1/4 DIA COLLAR, 1/2" SET BRIGHT CORNER POST CTL PNL LMWS 1 PH NO H/S CTL PNL LMWS 220/50/1 NO H/S CTL PNL LMWS 220/60/1 NO H/S CTL PNL LMWS 230V NO H/S CTL PNL LMWS 3 PH NO H/S DECAL, 300 DEG MAX FOR DR34 DECAL, BKI LOGO ADHESIVE BACK DECAL, DANGER HIGH VOLTAGE DECAL, LOGO LARGE DIE CAST DECAL, NSF DECAL, NSF TREATED LAMP NOTICE DECAL, REMOVABLE ROTORS DECAL, WATER PAN NOTICE DOOR ASSY LH OPER LMWS DOOR ASSY RH CUST LMWS FLEX HOSE STRAP GASKET, GREASE SMOKER GREASE DRAWER ASSY, LMWS GUARD, LAMPHOLDER PLATE SR KS LMWS HUB SPINNER, QUIK RELEASE FS/LMWS HUB, QUIK RELEASE (FS &LMWS) INSIDE H/S COVER PLATE INSPECTION PLATE CONTROL PANEL INSULATED MITT 13" INSULATION, KAOWOOL STRIP INSULATION, PEERLESS FIBER 3" INSULATION, RANGE 1" FIBERGLASS INSULATION,1"TK 35 Single Revolving Oven LMWS Part # LH0001 SRA056 LMWSA009 LMWSA026 SB5315 SB5317 SB5324 LMWSA031 LMWSA059 LMWSA069 N0023 NUT076 NUT083 SRWA072 LMWSA058 LMWSA082 FT0015 HT0002 HT0003 R0009 SB5333 SB5334 RIV170 RIV172 RIV173 SCR017 SCR008 SCR025 SCR031 SCR369 SCR236 SCR356 SCR448 SB5313 LMWSA077 SB5336 SB5306 SB0008 F0051 F0294 VB0004 WLMWSA012 LMWSA002 W0012 Replacement Parts LMWS Part Description LAMPHOLDER, RD PORCELAIN LATCH BLOCK, KS LID, CENTER LOUVER LMWS LID, LOUVER R&L LMWS OUTSIDE TOP FRAME WELD LMWS SIDE RACK ASSY MOTOR BLOWER ASSY, LMWS 220V MOTOR COVER MOTOR COVER BRACE MOTOR COVER SPACER NAME & RATING TAG, UL NUT, 10-24 PALNUTS NUT, SPEED PS-312010-S OUTSIDE H/S COVER PLATE OUTSIDE TOP PANEL, INSULATION PLUG, HOLE 1/2" QUARTZ TUBE, 200-220V QH1000T3 QUARTZ TUBE, 230-250V QH1000T3 RACK, 19 3/8 X 20 REMOV DISC ROTOR W/SPRING LMWS REMOV ROTOR PLAIN SIDE LMWS RIVET, 1/8 ALUM (.063-.125) RIVET, 1/8 CS ZINC (.187-.250) RIVET,1/8 SS (.187-.250) SCREW, 10 X 1 SLTD HEX WASHER SCREW, 10 X 1/2 PHIL TRUSS SCREW, 10-24 X 3/4 PHIL FL HD SCREW, 10-24 X 3/4 PHIL RD SCREW, 10-24 X 3/4 PHIL RD SCREW, 5/16-18 X 1 WHIZ'LOC SCREW, 5/16-18 X 5/16 SOC SET SCREW, STUD 10-24 X 1-1/4 WELD SHAFT & PULLEY WELD ASSY, LMWS SKIRT, BOTTOM LMWS SOLID BACK ASSY, LMWS BOTT SECTION SOLID BACK ASSY, LMWS TOP SECTION TERM BLOCK ASSY, 4 TB0001 TERMINAL, ELEC RING TONGUE TERMINAL, RING TONGUE V-BELT, 4L-910 WATER PAN WELDMENT, LMWS WELL, CALROD, LMWS WIRE, #12 GREEN 36 Single Revolving Oven Replacement Parts Accessories Part # Description SR, SR-2, SRW AND SRC G0052 INSULATED MITT 13" MF001 MEAT FORK MB0016 MEAT BASKET MB0018 CHICKEN BASKET WITH PRONGS MF0026 “V” SPIT KS G0052 INSULATED MITT 13" FR0001 FRAME MF0004 MEAT FORK (SINGLE SPIT) MB0001 MEAT BASKET (FR0001 FRAME NEEDED) MB0012 CHICKEN RACK BASKET (SB0680S KIT NEEDED) MB0016 MEAT BASKET (SB0680S KIT NEEDED) WASCA003 ROASTING PAN (FR0001 FRAME NEEDED) ASCA005B BAKING TRAY (FR0001 FRAME NEEDED) KSA059 COOKIE SHEET (FR0001 FRAME NEEDED) SB0680S PIN/NUT/WASHER KIT FOR KS CHAIN LMWS G0052 INSULATED MITT 13" MF0002 MEAT FORK MB0007 MEAT BASKET 37 Single Revolving Oven Wiring Diagrams Wiring Diagrams Model SR SR-2 SR-2 SR-2 SRC SRC SRC SRW SRW KS KS KS LMWS LMWS LMWS LMWS Part # SB10190000 SB11190100 SB11190000 SB11190200 SB30190000 SB30190300 SB30190200 SB20190100 SB20190000 SB60090200 SB60090300 SB60090000 SB53090000 SB53090200 SB53090100 SB53090300 Description 120V/208V/240V/1-3 Phase 120V/208V and 120V/240V/1-3 Phase 208V/220V/240V/1-3 Phase 220V/380V/3 Phase 120/208V and 120/240V/3 Phase 220V/380V/50 HZ/3 Phase 240V/3 Phase 120V/208V/240V/1-3 Phase 208V/220V/240V/1-3 Phase 220V/380V/50 HZ/3 Phase 208V/220V/240V/3 Phase 120V/208V and 120V/240V/1-3 Phase 120V/208V and 120V/240V/1 Phase 120V/208V/60 HZ/3 Phase 208V/220V/230V/1 Phase 220V/50 HZ/1 Phase 38 Figure # Figure 12 Figure 13 Figure 14 Figure 15 Figure 16 Figure 17 Figure 18 Figure 19 Figure 20 Figure 21 Figure 22 Figure 23 Figure 24 Figure 25 Figure 26 Figure 27 Single Revolving Oven Wiring Diagrams Figure 12. SR 120V/208V/240V/1-3 Phase 39 Single Revolving Oven Wiring Diagrams Figure 13. SR2 120V/208V and 120V/240V/1-3 Phase (Sheet 1 of 2) 40 Single Revolving Oven Wiring Diagrams Figure 13. SR2 120V/208V and 120V/240V/1-3 Phase (Sheet 2 of 2) 41 Single Revolving Oven Wiring Diagrams Figure 14. SR2 208V/220V/240V/1-3 Phase (Sheet 1 of 2) 42 Single Revolving Oven Wiring Diagrams Figure 14. SR2 208V/220V/240V/1-3 Phase (Sheet 2 of 2) 43 Single Revolving Oven Wiring Diagrams Figure 15. SR2 220V/380V/3 Phase (Sheet 1 of 2) 44 Single Revolving Oven Wiring Diagrams Figure 15. SR2 220V/380V/3 Phase (Sheet 2 of 2) 45 Single Revolving Oven Wiring Diagrams Figure 16. SRC 120/208V and 120/240V/3 Phase (Sheet 1 of 2) 46 Single Revolving Oven Wiring Diagrams Figure 16. SRC 120/208V and 120/240V/3 Phase (Sheet 2 of 2) 47 Single Revolving Oven Wiring Diagrams Figure 17. SRC 220V/380V/50 HZ/3 Phase (Sheet 1 of 2) 48 Single Revolving Oven Wiring Diagrams Figure 17. SRC 220V/380V/50 HZ/3 Phase (Sheet 2 of 2) 49 Single Revolving Oven Wiring Diagrams Figure 18. SRC 240V/3 Phase (Sheet 1 of 2) 50 Single Revolving Oven Wiring Diagrams Figure 18. SRC 240V/3 Phase (Sheet 2 of 2) 51 Single Revolving Oven Wiring Diagrams Figure 19. SRW 120V/208V/240V/1-3 Phase 52 Single Revolving Oven Wiring Diagrams Figure 20. SRW 208V/220V/240V/1-3 Phase 53 Single Revolving Oven Wiring Diagrams Figure 21. KS 220V/380V/50 HZ/3 Phase 54 Single Revolving Oven Wiring Diagrams Figure 22. KS 208V/220V/240V/3 Phase 55 Single Revolving Oven Wiring Diagrams Figure 23. KS 120V/208V and 120V/240V/1-3 Phase 56 Single Revolving Oven Wiring Diagrams Figure 24. LMWS 120V/208V and 120V/240V/1 Phase 57 Single Revolving Oven Wiring Diagrams Figure 25. LMWS 120V/208V/60 HZ/3 Phase 58 Single Revolving Oven Wiring Diagrams Figure 26. LMWS 208V/220V/230V/1 Phase 59 Single Revolving Oven Wiring Diagrams Figure 27. LMWS 220V/50 HZ/1 Phase 60 Single Revolving Oven Notes Notes 61 2812 Grandview Dr., Simpsonville, S.C. 29680, USA http://www.bkideas.com Made and printed in the U.S.A LI0276/0407 CS-TM-029.01 Revised 3/27/13 Single Revolving Oven Notes REVISION HISTORY REVISION 01 DATE 03/27/13 REVISED BY KW 2 DESCRIPTION Initial Release-Supersedes all previous releases