Download Pioneer-BDP05FD_51FD bluray player

ORDER NO.
RRV3753
BDP-05FD
Blu-ray Disc PLAYER
BDP-05FD
BDP-51FD
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
Type
Power Requirement
DVD
Region No.
BD
Region No.
BDP-05FD
KU/CA
AC 120 V
1
A
BDP-51FD
KU/CA
AC 120 V
1
A
For details, refer to "Important Check Points for good servicing".
Remarks
1
2
3
4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
B
WARNING
This product contains certain electrical parts contain chemicals which are known to the State of California to
cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 – Proposition 65
C
(FOR USA MODEL ONLY)
1. SAFETY PRECAUTIONS
The following check should be perfor med for the
continued protection of the customer and ser vice
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known ear th ground
(water pipe, conduit, etc.) by connecting a leakage
current tester such as Simpson Model 229-2 or
equivalent between the ear th ground and all exposed
metal par ts of the appliance (input/output terminals,
screwheads, metal overlays, control shaft, etc.). Plug
the AC line cord of the appliance directly into a 120V
AC 60 Hz outlet and turn the AC power switch on. Any
current measured must not exceed 0.5 mA.
D
E
Leakage
current
tester
Device
under
test
Reading should
not be above
0.5 mA
Test all
exposed metal
surfaces
Also test with
plug reversed
(Using AC adapter
plug as required)
Earth
ground
ANY MEASUREMENTS NOT WITHIN THE
LIMITS OUTLINED ABOVE ARE INDICATIVE
OF A POTENTIAL SHOCK HAZARD AND
MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related character istics. These are
often not evident from visual inspection nor the
protection afforded by them necessarily can be obtained
by using replacement components rated for voltage,
wattage, etc. Replacement par ts which have these
special safety character istics are identified in this
Service Manual.
Electr ical components having such features are
identified by marking with a
on the schematics and
on the parts list in this Service Manual.
The use of a substitute replacement component which
does not have the same safety characteristics as the
PIONEER recommended replacement one, shown in the
parts list in this Service Manual, may create shock, fire,
or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
infor mation, always consult the current PIONEER
Service Manual. A subscription to, or additional copies
of, PIONEER Ser vice Manual may be obtained at a
nominal charge from PIONEER.
AC Leakage Test
F
2
BDP-05FD
1
2
3
4
5
6
7
8
A
WARNING !
THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT
FOR CLASS 1.
A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE
APPARATUS.
---Laser Pickup specifications and Laser characteristics--For BD
Wave length : 405 nm
Operating output : 0.95 mW CW, Class 1M
Maximum output : Class 2 (under fault condition)
For DVD
Wave length : 660nm
Operating output : 1.06 mW CW, Class 1M
Maximum output : Class 2M (under fault condition)
For CD
Wave length : 785 nm
Operating output : 1.34 mW CW, Class 1M
Maximum output : Class 1M (under fault condition)
B
C
LABEL CHECK
The following caution label appears on your unit.
Location: inside of the unit
(Printed on the Rear Panel)
D
E
F
3
BDP-05FD
5
6
7
8
1
2
3
4
[Important Check Points for Good Servicing]
A
In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
B
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
C
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
D
a Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
E
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
4
BDP-05FD
1
2
3
4
5
6
7
8
CONTENTS
SAFETY INFORMATION.......................................................................................................................................................... 2
1. SERVICE PRECAUTIONS .................................................................................................................................................... 6
1.1 NOTES ON SOLDERING ............................................................................................................................................... 6
2. SPECIFICATIONS................................................................................................................................................................. 7
2.1 ACCESSORIES .............................................................................................................................................................. 7
2.2 SPECIFICATIONS .......................................................................................................................................................... 8
2.3 DISC/CONTENT FORMAT ........................................................................................................................................... 10
2.4 PANEL FACILITIES....................................................................................................................................................... 13
3. BASIC ITEMS FOR SERVICE ............................................................................................................................................ 16
3.1 CHECK POINTS AFTER SERVICING ......................................................................................................................... 16
3.2 PCB LOCATIONS ......................................................................................................................................................... 17
3.3 JIGS LIST ..................................................................................................................................................................... 18
4. BLOCK DIAGRAM .............................................................................................................................................................. 20
4.1 OVERALL WIRING DIAGRAM ..................................................................................................................................... 20
4.2 BLOCK DIAGRAM ........................................................................................................................................................ 22
4.3 POWER BLOCK DIAGRAM ......................................................................................................................................... 23
5. DIAGNOSIS ........................................................................................................................................................................ 25
5.1 POWER ON SEQUENCE............................................................................................................................................. 25
5.2 RESET ON SEQUENCE .............................................................................................................................................. 26
6. SERVICE MODE ................................................................................................................................................................. 28
6.1 OSD .............................................................................................................................................................................. 28
7. DISASSEMBLY ................................................................................................................................................................... 44
8. EACH SETTING AND ADJUSTMENT ................................................................................................................................ 51
8.1 NECESSARY ADJUSTMENT POINTS ........................................................................................................................ 51
8.2 MODEL SETTING ........................................................................................................................................................ 52
8.3 CPRM ID NUMBER AND DATA SETTING ................................................................................................................... 54
8.4 FIRMWARE UPDATE ................................................................................................................................................... 57
9. EXPLODED VIEWS AND PARTS LIST............................................................................................................................... 58
9.1 PACKING SECTION ..................................................................................................................................................... 58
9.2 EXTERIOR SECTION .................................................................................................................................................. 60
9.3 FRONT PANEL SECTION ............................................................................................................................................ 62
10. SCHEMATIC DIAGRAM .................................................................................................................................................... 64
10.1 MAIN ASSY (1/10)...................................................................................................................................................... 64
10.2 MAIN ASSY (2/10)...................................................................................................................................................... 68
10.3 MAIN ASSY (3/10)...................................................................................................................................................... 72
10.4 MAIN ASSY (4/10)...................................................................................................................................................... 74
10.5 MAIN ASSY (5/10)...................................................................................................................................................... 76
10.6 MAIN ASSY (6/10)...................................................................................................................................................... 78
10.7 MAIN ASSY (7/10)...................................................................................................................................................... 80
10.8 MAIN ASSY (8/10)...................................................................................................................................................... 84
10.9 MAIN ASSY (9/10)...................................................................................................................................................... 86
10.10 MAIN ASSY (10/10).................................................................................................................................................. 88
10.11 FLKY ASSY (BDP-05FD) ......................................................................................................................................... 92
10.12 FLKY ASSY (BDP-51FD) ......................................................................................................................................... 94
10.13 PSWB ASSY............................................................................................................................................................. 96
10.15 AUJB ASSY (1/2)...................................................................................................................................................... 98
10.16 AUJB ASSY (2/2).................................................................................................................................................... 100
10.14 CAPK ASSY ............................................................................................................................................................. 97
10.17 SYPS ASSY............................................................................................................................................................ 102
10.18 WAVEFORMS......................................................................................................................................................... 104
11. PCB CONNECTION DIAGRAM ...................................................................................................................................... 107
11.1 MAIN ASSY .............................................................................................................................................................. 108
11.2 FLKY, CAPK and PSWB ASSYS .............................................................................................................................. 112
11.3 AUJB ASSY .............................................................................................................................................................. 116
11.4 SYPS ASSY.............................................................................................................................................................. 118
12. PCB PARTS LIST ............................................................................................................................................................ 120
A
B
C
D
E
F
5
BDP-05FD
5
6
7
8
1
2
3
4
1. SERVICE PRECAUTIONS
1.1 NOTES ON SOLDERING
A
• For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
• Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 ºC.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 ºC in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Do NOT use a soldering iron whose tip temperature cannot be controlled.
B
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts:
• Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.
C
D
E
F
6
BDP-05FD
1
2
3
4
5
6
7
8
2. SPECIFICATIONS
2.1 ACCESSORIES
STANDBY/ON
A
Audio cable (white/red) x 1
Remote Control
( BDP-05FD : VXX3313)
( BDP-51FD : VXX3333)
(VDE1064) L=1.5m
OPEN/CLOSE
TV CONTROL
INPUT
SELECT
CH
VOL
Video cable (yellow) x 1
AUDIO SUBTITLE ANGLE FL DIMMER
(VDE1065) L=1.5m
B
ENTER
CLEAR
SECONDARY
AUDIO
VIDEO
OUTPUT
RESOLUTION
Power cable x 1
VIDEO SELECT PLAY MODE
( ADG7061 )
HOME MEDIA
GALLERY DISPLAY POPUP MENU
MENU
TOOLS
TOP MENU
C
ENTER
HOME
MENU
RETURN
PLAY
AA/R6 dry cell batteries
PREV
RED
PAUSE STOP
NEXT
GREEN BLUE YELLOW
VIDEO ADJUST
D
Warranty Card
Operating Instructions
BD PLAYER
( BDP-05FD : VRB1502 )
( BDP-51FD : VRB1505 )
E
F
7
BDP-05FD
5
6
7
8
1
2
3
4
2.2 SPECIFICATIONS
Model
A
BDP-05FD
Type
Blu-ray Disc PLAYER
Rated voltage
AC 120 V
Rated frequency
60 Hz
Power consumption
37 W
Power consumption (standby)
0.5 W
Weight
5.7 kg (12 lb 10 oz)
External dimensions (including projecting parts)
420 mm (W) x 124 mm (H) x 360 mm (D)
(16 9/16 in. (W) x 415/ 16 in. (H) x 143/16 in. (D))
Tolerable operating temperature
+5 °C to +35 °C (+41 °F to +95 °F)
Tolerable operating humidity
5 % to 85 % (no condensation)
Output terminals
B
Video
1 set, RCA jack (1.0 Vp-p (75 Ω))
S-Video
1 set, S-Video jack:
Y (luminance): 1.0 Vp-p (75Ω)
C (color): 0.286 Vp-p (75 Ω)
Component video
1 set, pin-plug jacks:
Y: 1.0 Vp-p (75 Ω)
PB, PR: 0.7 Vp-p (75 Ω)
Video outputs
Audio outputs
C
Digital audio outputs
Control
D
HDMI
1 set, 19-pin (5V, 150 mA)
2-channel (stereo)
Number of channels: 2, RCA jacks
7.1-channel (multi-channel: front left/
right, surround left/right, center,
surround back left/right, subwoofer)
Number of channels: 8, RCA jacks
Audio output level
200 mVrms (1 kHz, –20 dB)
Frequency response
4 Hz to 88 kHz (192 kHz sampling)
S/N ratio
115 dB
Dynamic range
103 dB
Total harmonic distortion
0.0015 %
Wow & flutter
Below measurable limits (±0.001 % W. PEAK)
Optical
1 set, Optical digital jack
Coaxial
1 set, RCA jack
Input
1 set, Minijack (3.5 ø)
Note
• The specifications and design of this product are subject to
change without notice.
• This product includes FontAvenue® fonts licensed by NEC
Corporation. FontAvenue is a registered trademark of NEC
Corporation.
E
F
8
BDP-05FD
1
2
3
4
5
6
7
Model
BDP-51FD
Type
Blu-ray Disc PLAYER
Rated voltage
AC 120 V
Rated frequency
60 Hz
Power consumption
34 W
Power consumption (standby)
0.5 W
Weight
5.6 kg (12 lb 6 oz)
External dimensions (including projecting parts)
420 mm (W) x 124 mm (H) x 361 mm (D)
8
A
(16 9/ 16 in. (W) x 415/ 16 in. (H) x 141/ 4 in. (D))
Tolerable operating temperature
+5 °C to +35 °C (+41 °F to +95 °F)
Tolerable operating humidity
5 % to 85 % (no condensation)
Output terminals
Video
1 set, RCA jack (1.0 Vp-p (75 Ω))
S-Video
1 set, S-Video jack:
Y (luminance): 1.0 Vp-p (75 Ω)
C (color): 0.286 Vp-p (75 Ω)
Component video
1 set, pin-plug jacks:
Y: 1.0 Vp-p (75 Ω)
PB, PR: 0.7 Vp-p (75 Ω)
Video outputs
Audio outputs
Digital audio outputs
Control
HDMI
1 set, 19-pin (5V, 150 mA)
2-channel (stereo)
Number of channels: 2, RCA jacks
7.1-channel (multi-channel: front left/
right, surround left/right, center,
surround back left/right, subwoofer)
Number of channels: 8, RCA jacks
Audio output level
200 mVrms (1 kHz, –20 dB)
Frequency response
4 Hz to 88 kHz (192 kHz sampling)
S/N ratio
115 dB
Dynamic range
103 dB
Total harmonic distortion
0.0015 %
Wow & flutter
Below measurable limits (±0.001 % W. PEAK)
Optical
1 set, Optical digital jack
B
C
Coaxial
1 set, RCA jack
Input
1 set, Minijack (3.5 ø)
D
Note
• The specifications and design of this product are subject to
change without notice.
• This product includes FontAvenue® fonts licensed by NEC
Corporation. FontAvenue is a registered trademark of NEC
Corporation.
E
F
9
BDP-05FD
5
6
7
8
1
2
3
4
2.3 DISC/CONTENT FORMAT
Playable discs
A
Discs with the logo marks below indicated on the disc label, package or jacket can be played.
Logo
Disc type
Application format
BDMV1
BDAV
DVD-Video
DVD VR
CD-DA
DTS-CD
DATA-DISC 2
BD-ROM
BD
BD-R
BD-RE
B
DVD-ROM
DVD-R
DVD
DVD-R DL
(Dual Layer)
C
DVD-RW
DVD+R
DVD+RW
CD-DA
(Music CD)
D
CD
CD-R
CD-RW
CD-ROM
1. Including the AVCHD format.
2. Discs on which music files are recorded
E
F
10
BDP-05FD
1
2
3
4
5
6
7
8
Discs that cannot be played
• HD DVDs
A
• DVD Audio discs
• DVD-RAM discs
• Non-finalized DVD-R/DVD-RW/DVD+R/DVD+RW discs in the
DVD-Video format and AVCHD format
• Non-finalized Dual Layer DVD-R discs in the DVD VR format
• SACDs
Manufactured under license from Dolby Laboratories. Dolby and the
double-D symbol are trademarks of Dolby Laboratories.
• Video CDs
• SVCDs
This player conforms to NTSC standards. Discs for which “NTSC” is
indicated on the disc label, package or jacket can be played.
“Blu-ray Disc” and
are trademarks.
B
is a trademark of DVD Form at/Logo Licensing Corporation. Manufactured under license under U.S. Patent #: 5,451,942;
5,956,674; 5,974,380; 5,978,762; 6,487,535 & other U.S. and worldwide
patents issued & pending. DTS isa registered trademark and the DTS
logos, Symbol, DTS-HD and DTS-HD Advanced Digital Out are
Note
trademarks of DTS, Inc. © 1996-2007 DTS, Inc. All Rights Reserved.
• Some discs cannot be played, even if one of the above logo
marks is indicated.
• To play 8 cm discs, set the disc in the 8 cm disc depression in
the center of the disc tray. No adapter is necessary. 8 cm BDROMs cannot be played.
Playing BDs
• BDs (BDMV) compatible with th e formats below can be played.
– Blu-ray Disc Read-Only (ROM) Format Version 2
– Blu-ray Disc Recordable (R) Format Version 2
About audio formats
– Blu-ray Disc Rewritable (RE) Format Version 3
The following audio formats are supported on this player:
• Dolby TrueHD
• Dolby Digital Plus
• Dolby Digital
• DTS-HD Master Audio
C
This player supports BD-ROM Profile 1 Version 1.1.
BONUSVIEW Functions such asplayback of secondary video
(Picture-in-Picture) and secondary audio can be used. For
details on secondary video and secondary audio playback, refer
to the disc’s instructions.
• DTS-HD High Resolution Audio
• DTS Digital Surround
• MPEG
“BONUSVIEW” is trademark of Blu-ray Disc Association.
• MPEG-2 AAC
When a BD-ROM is played, additional data may be stored in the
player’s memory area (local storage). If the message indicating
low memory (local storage) appears, erase the BDMV data.
• Linear PCM
To enjoy the surround sound of Dolby TrueHD, Dolby Digital Plus,
DTS-HD Master Audio and DTS-HDHigh Resolution Audio, it is
recommended to connect the player to an AV receiver or amplifier
compatible with these audio formats using an HDMI cable. After
loading a BD containing sound in one of these audio formats, select
the audio format on the menu screen.
D
• BDs (BDAV) compatible with the formats below can be played.
– Blu-ray Disc Recordable (R) Format Version 1
– Blu-ray Disc Rewritable (RE) Format Version 2
• Dual Layer BDs can be played.
• Music files recorded on BDs cannot be played.
• 8 cm BD-ROMs cannot be played.
E
F
11
BDP-05FD
5
6
7
8
1
2
3
Playing DVDs
A
4
DualDisc playback
• DVD-Video can be played.
• DVD-R/-RW/+R/+RW discs recorded in the DVD-Video format
can be played (finalize them before playing them on this player).
A DualDisc is a new two-sided disc, one side of which contains DVD
content — video, audio, etc. — while the other side contains nonDVD content such as digital audio material.
• DVD-R/-RW discs recorded in the VR format (Video Recording
format) can be played.
The DVD side of a DualDisc will be played on this player (excluding
any DVD-Audio content).
• This label indicates playback compatibility with DVD-RW discs
recorded in VR format (VideoRecording format). However, for
discs recorded with a record-only-once encrypted program,
playback can only be achieved using a CPRM compatible
device.
The non-DVD, audio side of the disc is not compatible with this
player.
It is possible that when loading or ejecting a DualDisc, the opposite
side to that being played will be scratched. Scratched discs may not
be playable.
For more detailed information on the DualDisc specification, please
refer to the disc manufacturer or disc retailer.
B
• DVDs recorded in the AVCHD format can be played (finalize
them before playing them on this player).
“AVCHD” and the “AVCHD” logo are trademarks of Matsushita
Electric Industrial Co., Ltd. and Sony Corporation.
• Music files recorded on DVD-R/-RW/+R/+RW discs can be
played.
C
• Dual Layer DVDs can be played. However, Non-finalized Dual
Layer DVD-R discs recorded in the VR format cannot be played
(finalize them before playing them on this player).
Playing discs created on computers
• It may not be possible to play DVD-R/-RW or CD-R/-RW discs
recorded using a personal recorder or computer. (This can be
due to various reasons, including disc properties, scratches, dirt
on the disc, dirt on the player’s lens, condensation and so on.)
• It may not be possible to play discs recorded using a computer
due to the application settings or environment. Record discs in
the proper format. For details, contact the dealer.
Playable files
Music files recorded on DVDs and CDs can be played.
• HD DVD, DVD Audio and DVD-RAM discs cannot be played.
Caution
About region numbers
Blu-ray Disc Player and BD-ROM or DVD-Video discs are assigned
region numbers according to the region in which they are sold.
This player’s region numbers are:
• BD-ROM: A
• DVD-Video: 1
• In DVD, only the one recorded by the ISO 9660 file system can be
played.
• Some files may not be playable.
• For some files, it may not bepossible to use certain functions
during playback.
• It may not be possible to play some files, even if they have the
extension of a file playable on this player.
Discs not including these numb ers cannot be played. Discs
playable on this player are as shown below.
• Files protected by DRM (Digital Rights Management) cannot be
played.
D
Supported music file formats
• BDs: A (including A) and ALL
• Windows Media™ Audio 9 (WMA9)
Bit rate: Up to 192 kbps
Sampling frequencies: 22.05 kHz, 32 kHz, 44.1 kHz and 48 kHz
• MPEG-1 Audio Layer 3 (MP3)
Bit rate: Up to 320 kbps
Sampling frequencies: 8 kHz, 11.025 kHz, 12 kHz, 16 kHz,
22.05 kHz, 24 kHz, 32 kHz, 44.1 kHz and 48 kHz
• DVDs: 1 (including 1) and ALL
Playing CDs
Playable file extensions
• Music CDs (CD-DAs and DTS-CDs) can be played.
E
• Music files
.wma and .mp3
• Music files recorded on CDs can be played.
• SACD, Video CD and Super VCD discs cannot be played.
• Regarding copy protected CDs: This player is designed to
conform to the specifications of the Audio CD format. This
player does not support the playback or function of discs that do
not conform to these specifications.
• Windows Media is either a registered trademark or trademark of
Microsoft Corporation in the United States and/or other countries.
• This product includes technology owned by Microsoft Corporation
and cannot be used or distributed without a license from
Microsoft Licensing, Inc.
F
12
BDP-05FD
1
2
3
4
5
6
7
8
2.4 PANEL FACILITIES
Front Panel
A
2
1
3
4
5
B
10
9
8
8
1
STANDBY/ON
Press to turn the power on and off.
2 Remote control sensor
Point the remote control to this, then operate it within approximately
23 feet.
The player may have trouble capturing remote control signals if
there is a fluorescent light nearby. If this happens, move the player
away from the fluorescent light.
3
Front panel display
4
Touch sensor – Touch the center of the words or marks lightly
to operate.
OPEN/CLOSE – Press to open and close the disc tray.
7
6
(BDP-05FD)
Disc tray
9 FL OFF indicator
This lights when Off is selected with FL DIMMER.
10 HD indicator
This lights when an HDMI cable is connected and video signals are
being output with a resolution of 1080/60i, 1080/60p, 1080/24p or
720/60p. It also lights when a component video cable is connected
and video signals are being output with a resolution of 1080/60i or
720/60p.
C
RESOLUTION – Press to switch the output video resolution from
the HDMI output or component video output terminals.
– Press to skip to the beginning of the previous title/
chapter/track/file. Press and hold to start reverse scanning.
– Press to skip to the beginning of the next title/
chapter/track/file. Press and hold to start forward scanning.
D
– Press during playback to pause. Press again to restrart
playback.
– Press to stop playback.
5
Press to start playback.
6 HDMI indicator
This lights when an HDMI-compatible device is connected.
7 Touch sensor indicator
This lights when the touch sensor is touched.
E
F
13
BDP-05FD
5
6
7
8
1
2
3
7 VIDEO SELECT
Press to switch the terminal from which the video signals are
output. Use to switch between digital output (HDMI output) and
analog output (Component Video output, S-Video output or Video
output) (the signals are only output from the selected video
output terminal).
Remote control unit
A
STANDBY/ON
OPEN/CLOSE
1
15
8 HOME MEDIA GALLERY
Press to display/hide the HomeMedia Gallery screen.
TV CONTROL
2
4
INPUT
SELECT
CH
VOL
AUDIO SUBTITLE ANGLE FL DIMMER
3
16
9 TOP MENU
Press to display the top menu of the BD-ROM or DVD-Video.
17
10
5
B
6
OUTPUT
RESOLUTION
18
VIDEO SELECT PLAY MODE
7
8
HOME MEDIA
DISPLAY POPUP MENU
GALLERY
MENU
20
TOOLS
TOP MENU
9
12
19
21
PREV/
NEXT – Press to skip to the beginning of the
previous/next title/chapter/track/file.
ENTER
HOME
MENU
/
/ – Press during playback to start reverse scanning.
While playback is paused, press for step reverse playback. Press
and hold while playback is paused for reverse slow motion
playback.
RETURN
11
23
C
PLAY
12
13
PREV
PAUSE
STOP
NEXT
RED
GREEN
BLUE
YELLOW
/
/
– Press during playback to start forward scanning.
While playback is paused, press for step forward playback.
Press and hold while playbackis paused for forward slow
motion playback.
VIDEO ADJUST
14
PLAY – Press to start playback.
PAUSE – Press to pause playback. Press again to restart
playback.
STOP– Press to stop playback.
22
10
/ / /
– Use to select items, change settings and move
the cursor.
ENTER – Press to execute the selected item or enter a setting
that has been changed, etc.
11
HOME MENU
Press to display/hide the Home Menu.
ENTER
CLEAR
SECONDARY
AUDIO
VIDEO
4
13 RED/GREEN/BLUE/YELLOW
Use these to navigate BD-ROM menus.
14 VIDEO ADJUST
Press to display/hide the Video Adjust menu.
15
OPEN/CLOSE
Press to open and close the disc tray.
D
BD PLAYER
16 FL DIMMER
Press to switch the brightness of the front panel display. The FL OFF
indicator lights when Off is selected.
1
STANDBY/ON
Press to turn the power on and off.
17 ANGLE
Press to switch the BD-ROM or DVD-Video camera angles.
2 TV CONTROL
Your TV can be controlled using the player’s remote control.
– Press to turn the TV’s power on and off.
18 OUTPUT RESOLUTION
Use these to switch the output video resolution from the HDMI OUT
or COMPONENT VIDEO output terminals.
INPUT SELECT– Press to switch the TV’s input.
CH +/– – Press to select the TV channel.
19 PLAY MODE
Press to display/hide the Play Mode screen.
VOL +/– – Press to adjust the volume.
E
3 AUDIO
Press to switch the audio streams/channels.
20 POP UP MENU/MENU
Press to display the BD-ROM or DVD-Video menus.
4 SUBTITLE
Press to switch the subtitles.
21 DISPLAY
Press to display disc information.
5
22
TOOLS
Press to display/hide the TOOLSmenu.
6
F
Number buttons – Use these to select and play the title/
chapter/track you want to watch or listen to and to select items
from menus.
CLEAR – Press to clear the numeric number, etc.
ENTER – Press to execute the selected item or enter a setting
that has been changed, etc.
SECONDARY AUDIO– When playing a BD-ROM on which
secondary audio is recorded, press to switch to the secondary
audio.
SECONDARY VIDEO– When playing a BD-ROM on which
secondary video (Picture-in-Picture) is recorded, press to switch
to the secondary video.
14
23
RETURN
Press to return to the previous screen.
BDP-05FD
1
2
3
4
5
6
7
8
Front Panel Display
A
1 2
3
PQLS
24HZ
CONTROL 50HZ
60HZ
6
5
4
1
Lights during playback.
4 Counter display
Displays the title/chapter/track number, elapsed time, etc.
2
Lights when the pause mode is set.
5 24HZ/50HZ/60HZ
The frequency of the video frame or field being output lights.
3 PQLS
Lights when the PQLS function is activated.
6 CONTROL
Lights when the “HDMI Control” function is activated.
B
Rear Panel
1
2
3
FRONT SURROUND
4
5
C
SURROUND
CENTER
BACK
L
L
R
R
AUDIO OUT (2 ch)
AUDIO OUT (7.1 ch)
SUB WOOFER
VIDEO OUT
COMPONENT VIDEO
DIGITAL
OUT
AC IN
Y
COAXIAL
CONTROL
IN
HDMI OUT
PB
VIDEO
PR
S-VIDEO
OPTICAL
7
6
D
1 DIGITAL OUT (COAXIAL/OPTICAL)
Connect with the digital audio input terminal on an AV receiver or
amplifier, etc.
2 AUDIO OUT (2 ch) terminals
Connect with the audio input terminals on a TV, AV receiver or
amplifier, etc.
3 AUDIO OUT (7.1 ch) terminals
Connect with the multi-channel (7.1- or 5.1-channel) audio input
terminals on an AV receiver or amplifier, etc.
4
VIDEO OUT terminals
VIDEO – Connect with the video input terminal on a TV, AV
receiver or amplifier, etc.
Caution
• Be sure to connect cables for outputting the audio and video
signals.
• When connected via System Control, point the remote control
toward the connected component (such as an AV receiver or
amplifier). The remote will not work correctly when pointed at
this player.
• You cannot use System Control with components that do not
have a System Control terminal or with components
manufactured by companies other than Pioneer.
E
S-VIDEO – Connect with the S-Video input terminal on a TV, AV
receiver or amplifier, etc.
COMPONENT VIDEO – Connect with the component video
input terminals on a TV, AV receiver or amplifier, etc.
5 AC IN
Connect the power cord here.
6 HDMI OUT terminal
Connect with an HDMI-compatible TV, AV receiver or amplifier, etc.
7 CONTROL IN terminal
Use to control this player from the remote sensor of another Pioneer
component with a CONTROL OUT terminal and bearing the
mark. Connect the CONTROL OUT of the other component to the
CONTROL IN of this player using a mini-plug cord.
F
15
BDP-05FD
5
6
7
8
1
2
3
4
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING
A
Items to be checked after repair (BD players)
To ensure the quality of the product after repair, check the recommended items shown below:
No.
B
Procedures
Item to be checked
The version must be the latest.
If the version is not the latest, update the firmware.
1
Check the version of the firmware in Service mode.
2
Check if all the symptoms pointed out by the customer have been
The symptoms in question must not be reproduced.
addressed. If a symptom pointed out by the customer is
Video, audio, and operations must be normal.
attributable to a particular disc, that disc must be played back.
3
Measure playback error rates at the innermost and outermost
tracks, by playing back the following discs:
BD-ROM test disc (GGV1308)
DVD test disc (GGV1025)
The error rates must be 1.0e-3 or less.
This procedure can determine if the drive is degraded.
4
Check playback of a CD disc (track search).
Audio and operations, such as a search, must be normal.
5
Check playback of a DVD disc (menu operations, title/chapter
search).
Video, audio, and operations, such as a search, must be normal.
6
Check playback of a BD disc (menu operations, title/chapter
search).
Video, audio, and operations, such as a search, must be normal.
7
Check the cabinet.
Check for any scratches or dirt that have been made or attached
on the cabinet after receiving the product for repair.
C
See the table below for the items to be checked regarding video and audio:
Item to be checked regarding video
Item to be checked regarding audio
Block noise
Distortion
Horizontal noise
Noise
Dot noise
Volume too low
Disturbed image (video jumpiness)
Volume too high
Too dark
Volume fluctuating
Too bright
Sound interrupted
Color disappearance
D
Mottled color
Cleaning
Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools:
Position to be cleaned
Cleaning tools
Pickup lenses
Cleaning liquid : GEM1004
Cleaning paper : GED-008
Position to be cleaned
Cleaning tools
Fans
Cleaning paper : GED-008
E
F
16
BDP-05FD
1
2
3
4
5
6
7
8
3.2 PCB LOCATIONS
A
G SYPS ASSY
D AUJB ASSY
SERVICE MAIN ASSY
B
A MAIN ASSY
ATAB ASSY
DRIVE ASSY BDV-103
C
F
CAPK ASSY
D
BDP-05FD ONLY
B
NOTES:
-
FLKY ASSY
PSWB ASSY
C
Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Mark No.
Description
Part No.
Mark No.
Description
E
Part No.
LIST OF ASSEMBLIES
1..CAPK ASSY (BDP-05FD only)
VWG2614
NSP
NSP
1..AUJB ASSY (BDP-05FD)
1..AUJB ASSY (BDP-51FD)
VWG2615
VWG2632
NSP
NSP
1..FLKB ASSY (BDP-05FD)
1..FLKB ASSY (BDP-51FD)
2..FLKY ASSY (BDP-05FD)
2..FLKY ASSY (BDP-51FD)
2..PSWB ASSY
VWM2463
VWM2481
VWG2612
VWG2625
VWG2613
NSP
NSP
>
1..SERVICE MAIN ASSY (BDP-05FD)
1..SERVICE MAIN ASSY (BDP-51FD)
2..MAIN ASSY (BDP2.0)(BDP-05FD)
2..MAIN ASSY (BDP2.0)(BDP-51FD)
2..ATAB ASSY (BDP2.0)
VXX3326
VXX3328
VWV2315
VWV2375
VWV2360
1..SYPS ASSY
VWR1415
1..DRIVE ASSY BDV-103
VXX3325
F
17
BDP-05FD
5
6
7
8
1
2
3
4
3.3 JIGS LIST
Jigs List
A
Name
Service Remote Control Unit
DVD Test Disc (DVD-Video)
BD-ROM Test Disc
ID Data Disc for Blu-ray player Type 2 Vol 1.0
Disc Ejection Rod
Jig No.
Remarks
Adjustment, diagnosis
Check of DVD-Video
Check of BD-ROM
Diagnosis (ID data setting)
Emergency Disc Ejection
GGF1067
GGV1025
GGV1308
GGV1324
GGF1529
B
C
D
E
F
18
BDP-05FD
1
2
3
4
5
6
7
8
A
B
C
D
E
F
19
BDP-05FD
5
6
7
8
1
2
3
4
4. BLOCK DIAGRAM
4.1 OVERALL WIRING DIAGRAM
A
BD/DVD/CD DRIVE
CN401(3/3)
1
GND
2
GND
3
SW+5V_W
B
BDV-103-XP/5
DKN1285-A
SW+12V_W
4
ATAPI CONNECTOR
VKP2408-A
DKN1285-A
ATAB
GND
8
D
SW+5V
9
G
SW+5V
10
GND
11
CN201
SYPS
ASSY
(VWR1415)
PF13PP-D32
B13B-PH-K-S
GND
1
2
3
SW+2.5V
SW+2.5V
GND
4
GND
5
6
7
SW+1.5V
SW+1.5V
GND
8
GND
9
GNDA
10
E
11
SW+12A
12
13
AKM1284-A
1
2
3
2
3
4
5
1
RESET#
1
GND
2
DD7
3
DD8
40
RESET#
1
39
GND
2
38
DD7
3
37
DD8
36
5
4
35
DD6
6
DD9
34
7
DD5
33
8
DD10
32
9
DD4
31
10
DD11
30
11
DD3
29
12
28
13
DD12
27
DD2
14
DD13
26
15
DD1
25
16
DD14
24
17
4
5
6
7
8
9
10
11
12
RS232C
13
RKN1052-A
CN1601
3
4
SCIFRXD
SH_UART1TXD
1
AC INLET ASSY
When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS
LIST" or "PCB PARTS LIST".
The > mark found on some component parts indicates the importance of the safety
factor of the part. Therefore, when replacing, be sure to use parts of identical
designation.
: The power supply is shown with the marked box.
20
BDP-05FD
1
4
5
7
8
9
10
11
12
13
6
DD6
6
DD9
DD5
7
8
DD10
DD4
9
10
DD11
DD3
11
12
DD12
15
14
13
DD2
14
DD13
17
18
19
20
16
15
DD1
DD14
16
17
18
DD0
DD0
22
21
23
18
DD15
GND
19
20
KEYPIN
20
19
GND
DMARQ
21
22
18
DIOW#
23
17
GND
24
16
DIOR#
25
15
GND
26
14
IORDY
27
13
CSEL
28
12
DMACK#
29
11
30
GND
10
31
INTRQ
9
32
RESERVED
8
33
7
34
DA1
6
35
PDIAG#
5
DA0
36
4
37
DA2
3
CS0#
38
2
MAIN ASSY
(VXX3326 : BDP-05FD)
(VXX3328 : BDP-51FD)
CN7001
3-176976-4
/KU/CA:ADG7061-B
CS1#
GND
11
2
AC POWER CORD
A A 1/10 - A 10/10
9
10
CN101
ADX7723-A
F
8
GND
N
7
SCIFTXD
L
GNDA
SW-12A
6
11
7
5
V+3E
EV+6V
10
6
4
NC
P_ON
9
5
3
M32_UARTRXD
GND
2
8
4
SW+12V
M32_UARTTXD
3
1
SH_UART1RTS
GND
7
SW-23V
2
VKN2050-A
6
1
VKN1818-A
AKM1282-A
SH_UART1CTS
GND
B11B-PH-K-S
GND
VWV2360
CN1501
CN7002
5
PF11PP6D25
SH_UART1RXD
CN202
DASP#
1
B4B-EH -A
39
VDA2182-A
40
3
4
1
2
CN203
DD15
VKN1816-A
CN9001
C
19
20
22
21
CN9003
KEYPIN
GND
DMARQ
21
22
24
25
26
27
28
29
30
31
32
33
34
23
DIOW#
23
24
GND
DIOR#
25
GND
26
IORDY
27
CSEL
28
DMACK#
29
GND
30
31
INTRQ
RESERVED
32
33
DA1
35
34
37
36
35
PDIAG#
DA0
36
DA2
39
38
37
CS0#
38
CS1#
DASP#
GND
40
39
40
CN401(1/3)
2
3
4
5
6
7
8
A
BDP-05FD Only
C
CN2
1
3
2
3
GND
4
4
GND
KEY0
2
VDA2186-A
1
B
CN3
B
VKN1236-A
LED_PON
5
1
5
GND
KEY1
3
4
GND
V3EV
2
1
2
3
CN991
4
VKN1236-A
CN1
5
VKN1374-A
KEY_SENSE
VDA2186-A
PSWB ASSY
(VWG2613)
5
CAPK ASSY
(VWG2614)
V+12SW
F
VKN1236-A
FLKY ASSY
(VWG2612 : BDP-05FD)
(VWG2625 : BDP-51FD)
CN1
30
V-23SW
29
CN4401
VKN1620-A
C
VDA2183-A
1
28
KEY1
KEY0
2
3
27
4
GND
26
FLSTB
25
6
5
24
GND
FLCLK
7
22
21
20
19
18
17
15
23
8
9
GND
FLDATA
GND
10
11
V+3D
12
GND
V+12SW
13
14
GND
14
13
12
16
15
GND
GND
16
17
V+3E
GND
18
11
GND
LED_HDMI
19
20
10
9
GND
LED_BLUE
21
22
8
23
GND
7
LED_PON
24
6
25
GND
5
GND
26
3
2
4
27
LED_FLOFF
28
V+5E
IR
29
30
VDA2185-A
LED_HD/DOOR_OPEN
1
VKN1290-A
CN8901
1
VKN1617-A
2
V-12A
V-12A
GNDA
3
V+12A
4
V+12A
5
GNDA
6
XAMUTE
7
V+5E
8
ADATA0
9
GND
10
ADATA2
11
GND
12
ADATA3
13
GND
14
ADATA1
15
GND
16
BCLK
17
GND
18
LRCK
19
GND
20
AMCLK
21
DAC_ML2
22
DAC_MDO
23
DAC_MC
24
DAC_ML
25
GND
26
V+3D
27
27
CN1
26
VKN1617-A
25
24
23
22
21
20
19
18
D D 1/2 - D 2/2
AUJB ASSY
(VWG2615 : BDP-05FD)
(VWG2632 : BDP-51FD)
17
16
15
14
13
12
11
10
9
8
AUDIO OUT
7.1ch
7
2ch
6
5
4
3
2
VKB1160
(VWG2615)
VKB1159
(VWG2632)
JA2
DIGITAL AUDIO OUT
AKM1273-A
FAN_DRIVE
1
GND
2
HDMI OUT
DKP3748
JA3701
JA3
VKB1138
(VWG2615)
VKB1265
(VWG2632)
JA4
JA1
E
L
FL SL SBL
FR SR SBR
Center
Lfe
VIDEO OUT
VKX1023
VKX1024
(VWV2375)
JA8001
VKB1160
(VWG2615)
VKB1159
(VWG2632)
VKB1129
(VWG2615)
VKB1130
(VWG2632)
1
R
CN8801
VKB1198
VKB1165
(VWV2375)
AKB7159
AKB7145
(VWV2375)
JA6002
JA6001
AKP7220
Y
JA5001
RKN1004
Pb
JA4351
F
Pr
FAN MOTOR
SR
VXM1122
Co-Axial
optical
COMPONENT
SD CARD
COMPOSITE
S-VIDEO
21
BDP-05FD
5
D
6
7
8
F
1
ATAB
22
2
F
CAPK ASSY
3
B
FLKY ASSY
IC2
FL Driver
PDC182A
12MHz
CN7001
CERALOCK
CN7002
Regulator
for ICE
27MHz
X'tal
IC3801
PLL
PDJ015A
AMCLK2
33MHz
AMCLK1
36MHz
SR
AMCLK for DAC
33/ 36MHz
AMCLK for HDMI
33/ 36MHz
I2C
IC6301
FAN
CN8801
ADV7340
Video ENC
JA4351
SR
IC5001
HDMI
IC
SII9134CTU
Video AMP
NJM2566A
IC6001
VIDEO
Y,C,
Yp.Cb,Cr OUT
PXDATA, SDPXDATA
PXDATA
SPDIF,SHGPIO0 5
SPDIF
JA6002
Component
Video out
JA6001
Composite/ S
Video out
JA5001
HDMI output
JA8001
Digital Audio output
CN8901
AUDIO
to BOARD
B
CN1301
SH+M32 JTAG
VMCLK
27MHz
Audio
Out
AMCLK, ABCLK, ALRCK
ADATA0 ,ADATA1
ADATA2, ADATA3
JA3701
SD card
connector
Others
HDMI Video
Analog Video
HDMI Audio
Digital Audio
Analog Audio
IC8401
audio DAC
WM8740
IC8301
audio DAC
WM8740
IC8201
audio DAC
WM8740
IC8101
audio DAC
WM8740
JA8401
Lsb,Rsb
JA8301
C,LFE
JA8201
Ls,Rs
JA8102
FL,FR
JA8101
Lch,Rch
2
IC4001
Sub
microcomputer
PDC178A8
I2C
IC1001
MAIN LSI
R8A34019BG
SH BUS
512Mb
A MAIN ASSY
CN
4401
PATA
32b
IC3501
NOR FLASH
S29GL512P11TFI020
BDP-05FD and
BDP-51FD
IC1
Touch key
CY8C2043412LKXI
CN
1501
E
32b
D
IC2301
DDR2 - 0
EDE5108AJ IC2401
DDR2 - 0
BG
512Mb EDE5108AJ
BG
512Mb
C
BD
DRIVE
BD DRIVE
IC2101
DDR2 - 0
EDE5108AJ IC2201
DDR2 - 0
BG
512Mb EDE5108AJ
BG
512Mb
A
IC3101
DDR2 - 1
EDE5116AJ IC3202
DDR2 - 1
BG
512Mb EDE5116AJ
BG
512Mb
1
3
4
4.2 BLOCK DIAGRAM
D AUJB ASSY
G
SYPS
ASSY
BDP-05FD Only
C
PSWB
ASSY
BDP-05FD
4
5
6
7
8
4.3 POWER BLOCK DIAGRAM
BDP-05FD POWER BLOCK DIAGRAM
A
M A
I
N
from SYPS
CN7001
13 SW-12A V-12ASW
11 SW+12A
TR:Q8181
AUDIO Digital:IC8101
TR:Q8171
V+12ASW
7 SW+1.5V V+1R5SW
6
3 SW+2.5V V+2R5SW
2
BIAS
V+1R1S
ON/OFF
V+5SW
ON/OFF
V+3D
V+2R5SW
1.8VREG:IC7201
V+3D
8 V+5E
V+5E
V+12A
5 V+12A
4
2 V-12A
1
RESET:IC4201
1.1VREG:IC7101 V+1R1D
to AUJB
CN8901
27 V+3D
IC1001
SKY
V+3S
V+1R1PLL
V+3PLL
V+1R1VS
V+3VS
V+1R8D
V-12A
from MAIN
A U J B
CN001
1 V+3D
V+3D
IC6, IC7, IC14, IC15
VDD3R3 AUDIO DAC
20 V+5E
V+5E
MUTE
V+12A
23 V+12A
24
V-12A
26 V-12A
5VREG:IC005
27
V+12
VCC5
V-12
IC8~13, IC16~21
LPF
B
V+1R8S
V+1R8ch0-1
V+2R5SW
V+1R8CH0
1.8VREG:IC2151
ON/OFF
DDR_PSW
V+2R5SW
IC2601
DDR2 ch0:IC2101
DDR2 ch0:IC2201
1.8VREG:IC3151
VTT-ch0
DDR2 ch0:IC2301
V+2R5SW
ON/OFF
DDR_PSW
VTT-CH1
IC3301
DDR2 ch0:IC2401
1.8VREG:IC2351
ON/OFF
DDR_PSW
V+1R8ch1-1
V+1R8CH1
DDR2 ch1:IC3101
DDR2 ch1:IC3201
V+1R8ch0-2
V+1R8ch1-2
C
V+2R5SW
to IC7201 ON/OFF
from SYPS
to IC7101_6pin(BIAS)
CN7002
10 SW+5V V+5SW
3.3V REG:IC7301
9
7 EV+6V
V+6E
FLASH MEMORY
4 SW+12V V+12SW
IC3501
to DDR_PSW
CLK GEN
IC3801
V+3D
V+3CG
P W S B
from FLKY
CN91
LED
V+12 V+12 5
V+3FM
SD card
connetcor
CLK BUFFER
V+3SPDIF IC8001
2 SW-23V
JA3701
4
V+3SD
V+12
SD
Card
V-23SW
C A P K
V+5SW
V+3VA
3.3V REG:IC7311
V+3AAD
from FLKY
CN1
1 V3EV V3EV
V+3DAD
VIDEO
DAC
V+1R8DAD
V+5SW
V+1R8VD V+1R8DPD
1.8V REG:IC7331
ON/OFF
D
IC 1
SENCE IC
IC6301
V+3D
V+3E
V+5SW
CLK BUFFER:IC5401
V+3ICS
V+5SW
3.3V REG:IC5311
V+3HDMI
H D M I
HDMI
F
JA5001
21 DUMMY2
(KEY0), (KEY1)
L
K Y
V+3H
V+1R8HDMI
V+5SW
V+1R8H
V+6E
V+6E
IC5001
18 +5V
IC 1
IR
1.8V REG:IC5301
ON/OFF
V+5SW
5V REG:IC7421
V+5V
5V REG:IC7501
to CAPK
CN2
1 V3E
E
V+1R8LHA
VIDEO AMP:IC6001
to FLKB
from MAIN
CN4401
28 V+5E
V+5E
CN1
3 V5EV
17 V+3E
V+3E
V5EV
14 V3EV V3EV
LED
to PWSB
CN3
1 V+12
V+5E
13 V+12SW V+12SW 18 V+12 V+12
RESET:IC4002
SR IN:IC4351
11 V+3D
V+6E
3.3V REG:IC4101
V+3E
V+6E
5V REG:IC5321 V+5HD
SUB-COM
IC4001
1 V-23SW
V+3D
V-23SW
V+12SW
Q8801
SW3R3
V-23V
T R
Q 1
FLDC-(-22V)
FAN
V-23SW
20 SW3
R3
30 V-23
V
IC 2
FL DRIVER
CN8801
1 V+12SW
F
A
N
T R
Q 2
F
F- F
F+ L
FLDC+(-18V)
23
BDP-05FD
5
6
7
8
1
2
3
4
BDP-51FD POWER BLOCK DIAGRAM
A
M A
I
N
from SYPS
CN7001
13 SW-12A V-12ASW
11 SW+12A
TR: Q8181
AUDIO Digital: IC8101
TR: Q8171
V+12ASW
7 SW+1.5V V+1R5SW
6
3 SW+2.5V V+2R5SW
2
BIAS
V+1R1S
ON/OFF
V+5SW
B
V+2R5SW
ON/OFF
V+3D
1.8vREG : IC7201
IC1001
SKY
8 V+5E
V+5E
V+12A
V-12A
V+3S
V+1R1PLL
V+3PLL
V+1R1VS
V+3VS
V+1R8D
V +3D
5 V+12A
4
2 V-12A
1
RESET : IC4201
1.1vREG:IC7101 V+1R1D
to AUJB
CN8901
27 V+3D
from MAIN
A U J B
CN001
1 V+3D
IC6, IC7, IC14, IC15
V +3D
VDD3R3 AUDIO DAC
20 V+5E
V+5E
MUTE
V+12A
23 V+12A
24
V-12A
26 V-12A
5vREG : IC005
27
V+12
VCC5
V-12
IC8~13, IC16~21
LPF
V+1R8S
V+1R8ch0-1
V+1R8CH0
V+2R5SW 1.8vREG : IC2151
ON/OFF
DDR_PSW
V+2R5SW
IC2601
DDR2 ch0 : IC2101
DDR2 ch0 : IC2201
1.8vREG : IC3151
VTT-ch0
DDR2 ch0 : IC2301
V+1R8ch1-1 DDR2 ch1 : IC3101
V+1R8CH1
ON/OFF
DDR_PSW
VTT-CH1
IC3301
DDR2 ch0 : IC2401
V+2R5SW 1.8vREG : IC2351
V+1R8ch0-2
ON/OFF
DDR_PSW
C
DDR2 ch1 : IC3201
V+1R8ch1-2
V+2R5SW
to IC7201 ON/OFF
to DDR_PSW
from SYPS
to IC7101_6pin(BIAS)
CN7002
CLK GEN
10 SW+5V V+5SW
V+3D
IC3801
3.3v REG : IC7301
9
V+3CG
7 EV+6V
V+6E
FLASH MEMORY
V+3FM
CLK BUFFER
4 SW+12V V+12SW
IC3501
V+3SPDIF IC8001
2 SW-23V
V+3SD
V-23SW
P W S B
from FLKY
CN91
LED
V+12 V+12 5
SD card
connetcor
JA3701
4
SD
Card
D
V+5SW
3.3v REG : IC7311
V+3VA
V+5SW
V+5SW
E
V+5SW
CLK BUFFER: IC5401
V+3HDMI
V+3ICS
H D M I
3.3v REG: IC5311
V+3H
IC5001
V+1R8HDMI
1.8v REG: IC5301
V+1R8H
V+1R8LHA
ON/OFF
V+5SW
V+6E 5v REG: IC7421
V+5V VIDEO AMP : IC6001
V+6E 5v REG: IC7501
HDMI
F
JA5001
21 DUMMY2
(KEY0), (KEY1)
18 +5V
L
K Y
IC 1
IR
to FLKB
from MAIN
CN4401
28 V+5E
V+5E
CN1
3 V5EV
17 V+3E
V+3E
V5EV
14 V3EV V3EV
LED
V+5E
13 V+12SW V+12SW 18 V+12 V+12
RESET : IC4002
11 V+3D
SR IN: IC4351
V+6E 3.3v REG: IC4101
V+6E
F
5V REG: IC5321
to PWSB
CN3
1 V+12
V+3E
SUB-COM
IC4001
1 V-23SW
V+3D
V-23SW
FAN
V+12SW
Q8801
24
SW3R3
V-23V
T R
Q 1
FLDC-(-22V)
V+5HD
V-23SW
20 SW3
R3
30 V-23
V
IC 2
FL DRIVER
CN8801
1 V+12SW
F
A
N
F- F
F+ L
T R
Q 2 FLDC+(-18V)
BDP-05FD
1
2
3
4
V+12
5
6
7
8
5. DIAGNOSIS
5.1 POWER ON SEQUENCE
A
Power On Sequence
Pressing of the POWER key is detected by the IC4001 Submicrocomputer on the MAIN Assy.
The IC4001 then outputs a POWER_ON signal to the SYPS Assy.
After receiving the POWER_ON signal, the SYPS Assy activates, secondary
Power[SW+12 V], setting it to ON.
B
The R8A34019BG (IC1001), the core LSI, starts up. {RS-232C connectorCN1601,
log it to ON}
Communication between the R8A34019BG and the DDR2 SDRAM starts.
C
Communication between the R8A34019BG and the FLASH_IC starts.
It takes about 1 minute to complete the startup process.
D
Troubleshooting
Are the pins at CN7001 and CN7002 supplied with voltages?
MAIN ASSY(1/8) V+3S, V+3PLL with 3.3 voltages?
MAIN ASSY(1/8) V+1R8S with 1.8 voltages?
MAIN ASSY(1/8) V+1R1S with 1.1 voltages?
Is the reset signal H? (R1161)
Is the 27 MHz CLK oscillating? (R1141)
E
Power ON, and log of R8A34019BG stops with [DRAM failed].
R8A34019BG and communication failure of DDR memory.
Power ON, and log of R8A34019BG stops with [zboot failed].
R8A34019BG and communication failure of FLASH memory.
F
25
BDP-05FD
5
6
7
8
1
2
3
4
5.2 RESET ON SEQUENCE
ATIRESET
HDMI_RESET
NOR FLASH
Drive
A
R5034
HDMI
SiI9134
Main_LSI
B
R8A34019BG
3.3V 1.1V 1.8V
R1133
RESET2#
RESET_SKY#
MAIN LSI
NOR FLASH
C
0Ω
0Ω
D
Subcon
26
22k
SCON_XRESET
After detecting 3.3 V(E) ON/OFF,
hold 200ms SCON_XRESET "L"
and turn to SCON_XRESET "H".
By main reset release "H", Subcon
conducts operation.
3.3V
ResetIC
IC4002
1.1V
F
IC4201
1.1V
ResetIC
3.3V(E)
10k
3.3V
[detect 1.1 V Reset]
After detecting 1.1 V ON/OFF,
Transit ResetG "L", then instantly
to ResetG "H".
IC4001
E
BDP-05FD
1
2
3
4
5
6
7
8
A
1.Reset specification
[On start-up]
Receiving Power ON key, sub-microcomputer turns Power_ON signal to ”H”.
Receiving Power ON signal, power turns each SW power to ”ON”.
1.1 V turns ON.
Sub-microcomputer is (after 200ms) to Reset_SKY#, Reset 2#, Reset 3# ”L” turn to ”H”.
Power_ON
PON key
IN
B
200ms
Reset_SKY#,2#,3#
[At normal end]
Sub-microcomputer detects the pushing of Power key, then notifies PowerOFF to R8A34019BG by I2C.
Receiving PowerOFF notification, R8A34019BG conducts end processing.
R8A34019BG instructs PowerOFF to sub-microcomputer by I 2 C.
Sub-microcomputer turns Reset_SKY#, Reset 2#,Reset 3#,to ”L”, and after 200msec, PowerON signal to ”L”.
After 50msec, power turns each SW power to OFF.
C
Reset_SKY#,2#,3#
Power_ON
200ms
[Power abnormality]
*Reset operation in the case of 1.1 V drop.
Determine if ResetG becomes ”L”, then turn Reset# - Reset3# to “L”.
D
[At abnormal end]
ACOFF
By turning V+1R1D to OFF, ResetG# turns to ”L” by ResetIC.
Power_ON
E
V+1R1D
Reset
(IC4201 OUT)
Reset_SKY#,
Reset 2#,
Reset 3#
F
27
BDP-05FD
5
6
7
8
1
2
3
4
6. SERVICE MODE
6.1 OSD
A
Indication items for the OSDs for debugging
Remote Control
Unit Command
[ESC]+[DISP]
Screen
Indication Items for the OSDs
1st screen Service Indication (software information)
Product serial No./destination
Model No.
Released version No.
Revision No.
Submicrocomputer version data
Drive model No.
Drive version No.
Drive serial No.
DVD-Video region No.
BD-ROM region No.
CPRM ID
MAC address
2nd screen OSD Filter
Setup value of the OSD FILTER
B
[ESC]+[SIDE-B]
C
[ESC]+[DISP]+[2]
Remarks
The data must be displayed on
the subpage of the software
information screen.
1st screen Specifications 1 for error rate measurement (with OK/NG judgment)
To see the result, press ESC then SIDE-B.
Results of error rate measurement OK/NG
1st screen Specifications 2 for error rate measurement (for continuous playback)
Title/Chapter data
Playback duration data
LgcSct address data
Error rate data (error rate value)
[ESC]+[DISP]+[3]
1st screen ATA/ATAPI DEBUG OSD-Command history (ALL)
Packet command from the host
Error data from the status register
2nd screen ATA/ATAPI DEBUG OSD-Command history (ERROR)
Packet command that has been failed
Error Code
Command-specific information
D
3rd screen ATA/ATAPI DEBUG OSD-Drive maintenance data
Power ON/accumulated power-on duration
LD read power-on duration for the BD
LD read power-on duration for the DVD
Serial No. of the PU
4th screen ATA/ATAPI DEBUG OSD-Judgment of LD degradation
Judgment of degradation of the LD for the BD (OK/NG)
Judgment of degradation of the LD for the DVD (OK/NG)
Judgment of degradation of the LD for the CD (OK/NG)
Temperature inside the writer
E
[ESC]+[DISP]+[4]
Results of self-diagnosis
Version/Revision Nos. of the SKY chip
HDMI transmitter IC check
Communication check of the submicrocomputer
PLL synthesizer check
DRIVE check
F
28
BDP-05FD
1
2
3
4
5
6
7
8
A
Remote Control
Unit Command
[ESC]+[DISP]+[5]
Screen
Indication Items for the OSDs
Remarks
AV output data
Video data
*These data are to be used merely as
a guide, as they were designed to be
used for product development.
Video encoder data
Component output resolution
HDMI output resolution
Frame rate
Content resolution
Content aspect ratio
Data on VBID and WSS
CGMS-A/Copyright
APS
MacroVision
Aspect
Audio data
Sampling frequency
Category code (Number of Bits & definition)
Word Length
C/L bit: Indications on number of bits & status (Free/Once/Disable)
Audio muting status
LPCM/BitStream output
Number of output channels
HDMI ACP Type
[ESC]+[DISP]+[6]
[ESC]+[DISP]+[7]
B
C
HDMI data
* Two screens are to be used for HDMI data.
Connection status
* No data because screen specifications are to be designed by
engineers for the HDMI modules.
[ESC]+[DISP]+[8]
User Interface data
Logs for received keys
* No data because screen specifications are to be designed by
engineers for the UI modules.
[ESC]+[DISP]+[9]
D
Contents data
BD-ROM
HDMV
BD-J
Authoring maker
Total number of titles
BD-R/RE
BDMV
BDAV
AVCHD
Authoring maker
Total number of titles
DVD
BDMV
AVCHD
DVD-Video
DVD VR
Authoring maker
Total number of titles
CD
Total number of titles
PC-FILES
Total number of files
E
F
29
BDP-05FD
5
6
7
8
1
2
3
4
A
Remote Control
Unit Command
[ESC]+[DISP]+[10]
Screen
Indication Items for the OSDs
Remarks
Playback data (BD-ROM)
Title No.
Chapter No.
Elapsed time within a title
Video data
Primary Video Stream
Secondary Video Stream
Resolution
Source video aspect ratio
Frame rate
AACS data
CPI
CCI
APS
ICT
DOT
Audio data
Primary Audio Stream
Secondary Audio Stream
B
C
[ESC]+[DISP]+[11]
Playback data (BD-R/RE)
Title No.
Chapter No.
Elapsed time within a title
Navigation data
Playback stream format
SESF
ISDB
Video data
Video stream data
Playlist data (Virtual/Real-PlayList)
Playlist No.
Resolution
D
Source video aspect ratio
Frame rate
AACS data
CPI
CCI
APS
ICT
DOT
Audio data
Audio Stream data
E
F
30
BDP-05FD
1
2
3
4
5
6
7
8
A
Remote Control
Unit Command
[ESC]+[DISP]+[12]
Screen
Indication Items for the OSDs
Remarks
1st screen Playback data (DVD)
Playback status data (PLAY, PAUSE, etc.)
Navigation data
Title No.
Chapter No.
Numbers of all chapters in a title
Elapsed time within a title
Elapsed time within a chapter
Number of multi-angles
Number of the selected multi-angle
Number of audio streams
Number of selected audio
Number of sub-pictures
No. of the selected sub-picture or OFF
2nd screen
B
Video data
Frame rate
Resolution
Aspect ratio
Progressive frame data
Repeat first field data
C
Maximum quantity/current quantity of video stream buffer
Audio data
Codec type
Sampling frequency
Number of channels
(With LPCM) Quantization bit rate
Maximum quantity/current quantity of audio stream buffer
[ESC]+[DISP]+[13]
1st screen Playback data (A/V decoder)
D
Primary A/V decoder data for DVD and BD
Error data of the video decoder
Error data of the audio decoder
2nd screen
Secondary A/V decoder data for BD
Error data of the video decoder
Error data of the audio decoder
[ESC]+[DISP]+[14]
Playback data (CD)
Audio data
Playback track/all tracks
Playback duration of the track
Playback duration of the disc
Total duration of the track
Total duration of the disc
E
F
31
BDP-05FD
5
6
7
8
1
2
3
4
A
Remote Control
Unit Command
[ESC]+[DISP]+[15]
Screen
Indication Items for the OSDs
Remarks
1st screen Playback data (PC Files)
Movie
Format (MPEG1/MPEG2-PS/MPEG2-TS/WMV…)
Resolution
NTSC/PAL
Aspect
File name
B
2nd screen
Music
Format (MP3,WMA,WAV ...)
Fs
Bitrate
Channel number
Track name
3rd screen
Photo
Format (JPEG/GIF/PNG ...)
Resolution (Pixel)
Aspect
Date
File name
C
[ESC]+[AMON]+[TEST]
Destination setting screen
Input/setting of destination
[ESC]+[STEREO]
CPRM ID Registration screen
This screen is displayed when no ID is set.
ID registration
CPRM ID Clearing screen
This screen is displayed when the
ID has been set.
Clearing of the registered ID
* For details on how to shift screens, see "Service Indication Screens".
D
E
F
32
BDP-05FD
1
2
3
4
5
6
7
8
A
Service Indication Screens
1. Overview
On Service Indication screens, data that are retained by the System Controller are displayed with the aid of the remote
control unit for service (GGF1067). (Not for use by general users)
The maximum display area for on-screen displays is 64 one-byte characters (widthwise) × 17 lines (lengthwise).
2. How to Operate
To display indications for servicing, use the remote control unit for service.
• How to enter Service Indication mode
The following key input can be accepted either in Normal Startup mode or Service mode.
(1) Without any GUI displayed, press the ESC key.
B
ESC
(2) Then press the DISP key. The 1st screen (version data, etc.) is displayed.
C
1st screen (version data, etc.)
(3) To shift to a subsequent screen, press the corresponding key:
[2]: 2nd screen: Error rate measurement 2 (for continuous playback)
[3]: 3rd screen: ATA/ATAPI debugging (drive data)
• How to exit Service Indication mode
Press the ESC key.
• How to shift between screens
To shift to the next screen, press the DISP key. To shift to the previous screen, press the CX key.
• How to shift between subscreens
To shift to the next subscreen, press the DIG/ANA key. To shift to the previous subscreen, press the TEST key.
D
3. Overview of Screen Shifting
An overview of screen shifting in Service Indication mode is given below.
Press [DIG/ANA] key.
Press [DIG/ANA] key.
Press [2] key.
E
Packages
Data screen
OSD Filter
screen
Press [TEST] key.
Version Data
screen
(Press [ESC] key
then [DISP] key.)
Press [DISP] key.
Press [CX] key.
Press [TEST] key.
Error Rate
Measurement
2 screen
(for continuous
playback)
Press [DISP] key.
Press [CX] key.
ATA/ATAPI
DEBUG OSD
command history
(ALL)
Press [3] key.
* To exit any screen, press the ESC key.
* For details on the Error Rate Measurement 2 screen, see the "Specifications 2 for Error Rate Measurement
(for continuous playback)" .
* For details on the OSD Filter screen, see the "OSD Filter Setting".
F
33
BDP-05FD
5
6
7
8
1
A
2
3
4
4. Specifications of Version Data screen
• 1st screen (version data, etc)
B
00
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
1
2
3
4
5
6
7
8
9
1 Data on the model: Model name/destination
2 MODEL: Model No.
3 VERSION: Release version
4 REVISION: SVN Revision No.
C
5 DRIVE: Data on the built-in drive
Drive name: Judged as OK: The name assigned by the application program coincided with that obtained by the command.
Judged as NG: The name assigned by the application program did not coincide with that obtained by the
command.
DRIVE VER: Version of the firmware
Judged as OK: The version assigned by the application program coincided with that obtained by the command.
Judged as NG: The version assigned by the application program did not coincide with that obtained by the
command.
DRIVE S/N: Drive serial No. (For details on the drive serial No. indication, see the "Drive Serial No. Indication".)
D
6 SUBCON: Firmware version of the submicrocomputer (PIC)
Judged as OK : The version assigned by the application program coincided with that obtained by the command.
Judged as NG+ : The version obtained by the command is newer than that assigned by the application program.
Judged as NG- : The version obtained by the command is older than that assigned by the application program.
7 REGION: Region codes for DVD-VIDEO and BD-ROM of the player
The above screen example shows that the DVD region code is 1 and the BD region code is A.
If a region has not been set, "VIRGIN ROM" is displayed for the DVD, and "F" is displayed for BD.
8 CPRM ID: CPRM key No.
If it has not been set, "?????????" is displayed.
E
9 MAC ADDRESS: MAC ADDRESS value
If it has not been set, "?????????????????" is displayed.
• 2nd screen (OSD Filter Setting)
F
* For details on the OSD Filter screen, see the "OSD Filter Setting".
34
BDP-05FD
1
2
3
4
5
6
7
8
A
OSD Filter Setting
* The details of this section are to be determined later after register specifications are determined.
To display the Service Indication screen, press the ESC then DISP keys. Then press the DIG/ANA key once to switch to
the OSD Filter Setting screen. The above key inputs can be accepted either in Normal Startup mode or Checker mode.
• OSD Filter Setting screen
1
B
1 OSD Filter Setting value
ON
OFF
Key operations of the OSD Filter Setting screen
Key
C
Setting value
(*: Default)
Operation
Remarks
[<x3], [x3>]
For switching the OSD Filter Setting between
ON or OFF
OFF/ON ( * )
[<x3]: To set the OSD Brightness Filter to OFF
[x3>]: To set the OSD Brightness Filter to ON
[ESC]
For clearing data or exiting the current mode
−
−
* Use the remote control unit for service for key operation.
* A setting becomes valid as soon as it is set. The setting value will be stored in nonvolatile memory, as with the setting
values of the main unit. Therefore, the changed setting value will be retained upon the next power-on.
* About factory preset
• If the ESC then CLEAR keys are pressed ("No power off" command) for factory presetting, the setting will be reset to
default (ON).
• If the STOP and POWER keys on the main unit are pressed simultaneously for factory presetting, the current setting
will be retained.
D
E
F
35
BDP-05FD
5
6
7
8
1
A
2
3
4
Specifications 1 for Error Rate Measurement (with OK/NG judgment)
To measure the error rate for a certain duration, press the ESC then SIDE-B keys only during playback. The result of judgment
(OK/NG) will be displayed on the FL display and as an OSD.
To exit Error Rate Measurement mode, press the ESC key while the error rate is being measured.
After exiting Error Rate Measurement mode, if the ESC then SIDE-B keys are pressed again to reenter Error Rate Measurement mode, measurement of the error rate will start from the beginning.
The error rate is measured for up to 5 sessions, and the displayed result is updated after measurement for each session is
performed.
At the end of 5 sessions, the average error rate for the entire measurement range will be displayed. If measurement sessions
are interrupted before 5 sessions, the average error rate up to the point of interruption will be calculated and displayed.
B
A result will be judged as NG if the measured error rate exceeded the reference value. See "OK/NG judgment" below.
(Only when the average error rate is judged as NG, the tray will be opened.)
Operation Specifications
The following specifications must be met:
• When calculating an error rate, the denominator groups will be considered as shown below:
For DVD: 28-32 ECCs (448-512 sectors)
For BD: 95-105 clusters (3040-3360 sectors)
Then the measurement result will be displayed.
C
• For calculation of result judgment, the values of the above denominator groups will be multiplied by 5.
The measurement result along with the judgment result will be displayed.
• During error rate measurement, there should not be any video or audio problem (stuttering block noise, jumpiness, etc.)
in the playback signal.
• Data to be measured must be basically continuous.
Flowchart of DVD Error Rate Measurement (with OK/NG judgment)
Use the following flowchart just as a guide.
Start (during playback)
D
ALL ECC = 0
ALL Pi1 = 0
ALL Pi1L = 0
Error Rate
= ( Total Pi1 + Total Pi1L * 6 )
/ ( 30 [ECC] * 33024 )
Total ECC = 0
Total Pi1 = 0
Total Pi1L = 0
The error rate is displayed on the screen.
Total ECC =
30 [ECC]
ALL Pi1 = ALL Pi1 + Total Pi1
ALL Pi1L = ALL Pi1L + Total Pi1L
ALL ECC = ALL ECC + Total ECC
Yes
No
No
ALL ECC =
150 [ECC]
The "Read command" is issued.
Transfer Length = 20h = 2 [ECC]
E
Yes
The "Recorder Command" is issued.
(Read Error Information)
Error Rate
= ( ALL Pi1 + ALL Pi1L * 6 )
/ ( 150 [ECC] * 33024 )
Error data are obtained.
Pi1 = Number of ErrNumPi1
Pi1L = Number of UePiLine1
Judgment
Error Rate 1.00E-3 OK
Error Rate < 1.00E-3 NG
Total Pi1 = Total Pi1 + Pi1
Total Pi1L = Total Pi1L + Pi1L
Total ECC = Total ECC + 2
The error rate and judgment
result are displayed.
F
Finished
(during playback)
36
BDP-05FD
1
2
3
4
5
6
7
8
A
Flowchart of BD Error Rate Measurement (with OK/NG judgment)
Start (during playback)
ALL Cluster = 0
ALL Pi1 = 0
ALL Pi1L = 0
Error Rate
= ( Total Pi1 + Total Pi1L * 6 )
/ ( 96 [Cluster] * 33024 )
Total Cluster= 0
Total Pi1 = 0
Total Pi1L = 0
Total Cluster =
96 [ECC]
The error rate is displayed on the screen.
Yes
ALL Pi1 = ALL Pi1 + Total Pi1
ALL Pi1L = ALL Pi1L + Total Pi1L
ALL Cluster = ALL Cluster + Total Cluster
The "Read command" is issued.
Transfer Length = 100h = 8 [Cluster]
No
B
ALL Cluster =
480 [Cluster]
Yes
The "Recorder Command" is issued.
(Read Error Information)
Error Rate
= ( ALL Pi1 + ALL Pi1L * 6 )
/ ( 480 [Cluster] * 76880 )
Error data are obtained.
Pi1 = Number of ErrNumPi1
Pi1L = Number of UePiLine1
C
Judgment
Error Rate 1.00E-3 OK
Error Rate < 1.00E-3 NG
Total Pi1 = Total Pi1 + Pi1
Total Pi1L = Total Pi1L + Pi1L
Total Cluster = Total Cluster + 2
The error rate and judgment
result are displayed.
Formula for computation of error rate
• For DVD: See "Error Rate Computation Method for a DVD" .
• For BD: See "Error Rate Computation Method for a BD".
Finished
(during playback)
Display Formats on the FL display and as an OSD
D
Display format
Operation
FL
Only during playback, if keys are pressed, calculation of error
rate is started, and the results are displayed on the FL display
and as an OSD. The symbol (-) (which indicates that measurement is not finished) flashes.
The result of measurement is displayed.
If error rate measurement is completed before playback
finishes, the average error rate, the symbol (*) (which indicates
that the measurement is completed) and the judgment result
(OK/NG) will be displayed on the FL and as an OSD.
(When NG is displayed, if the tray is opened, the indications on
the FL display and screen will be retained.)
If error rate measurement is not completed before playback
finishes, the average error rate, the symbol (-) (which indicates
that measurement is not finished) and the judgment result
(ERROR) that indicates that the error rate measurement has
not been completed will be displayed on the FL display and as
an OSD.
OSD
ER x . x E - x
(At lights out)
ERR RATE : x.xE-x (At lights out)
ER x . x E - x -
(At lighting)
ERR RATE : x.xE-x- (At lighting)
ER x . x E - x ∗
ERR RATE : x.xE-∗ OK
(NG: OSD whole screen display
with red)
E
ER x . x E - x -
ERR RATE : x.xE-x- ERROR
* For details on the FL display, see "Specifications of Screen Display & FL Display."
* The layout for OSD depends on the mounting.
* "x.xE-X" in the above table indicates an error rate. E.g.: 3.5E-5 = 3.5X10-5
OK/NG judgment
Disc type
Reference value
Indication
DVD
BD
CD
1.0x10-3
1.0x10-3
OK/NG
OK/NG
F
No error rate measurement
37
BDP-05FD
5
6
7
8
1
A
2
3
4
Specifications 2 for Error Rate Measurement (for continuous playback)
How to Start
To measure the error rate continuously, press the ESC, DISP, then 2 keys, in that order, only during playback. The result will
be displayed as an OSD. The above keys can be accepted either in Normal Startup mode or Service mode.
* For details on key inputs, see also "3. Overview of Screen Shifting" of "Service Indication Screens."
[ERROR RATE MEASURING]
An error rate is measured during playback, and playback duration, title & chapter, address that is read, and error rate result
are displayed as an OSD.
* For details on commands for the drive, see "Drive Command Specifications."
B
The measurement method is as follows:
1. Press the ESC, DISP, then 2 keys, in that order, to start measurement.
2. The displayed result is updated after each measurement session is performed.
3. To exit Error Rate Measurement mode, press the ESC key while error rate is being measured.
* During Stop mode, the on-screen display will remain displayed.
Operation Specifications
The following specifications must be met:
• When calculating an error rate, the denominator groups will be considered as shown below:
For DVD: 28-32 ECCs (448-512 sectors)
For BD: 95-105 clusters (3040-3360 sectors)
Then the measurement result will be displayed.
C
• During error rate measurement, there should not be any video or audio problem (stuttering block noise, jumpiness, etc.)
in the playback signal.
• Data to be measured must be basically continuous.
Flowchart of DVD Error Rate Measurement (continuous playback)
Use the following flowchart just as a guide.
Start (during playback)
D
Total ECC = 0
Total Pi1 = 0
Total Pi1L = 0
Total ECC =
30 [ECC]
Yes
No
*2
Error Rate
= ( Total Pi1 + Total Pi1L * 6 )
/ ( 30 [ECC] * 33024 )
The "Read command" is issued. *1
Transfer Length = 20h = 2 [ECC]
E
The error rate is displayed
on the screen.
The "Recorder Command" is issued.
(Read Error Information)
Error data are obtained.
Pi1 = Number of ErrNumPi1
Pi1L = Number of UePiLine1
*1 : The Transfer Length for the Read command in this flowchart is
assumed to be 20h, as an example.
*2 : Number of the total read blocks
30 [ECC] ∗ 33024 = 30 [ECC] ∗ 1 ECC [ 172 bytes ∗ 192 rows]
Total Pi1 = Total Pi1 + Pi1
Total Pi1L = Total Pi1L + Pi1L
Total ECC = Total ECC + 2
F
38
BDP-05FD
1
2
3
4
5
6
7
8
A
Flowchart of BD Error Rate Measurement (continuous playback)
Use the following flowchart just as a guide.
Start (during playback)
Total Cluster = 0
Total Pi1 = 0
Total Pi1L = 0
Total Cluster =
96 [Cluster]
Yes
B
No
*2
Error Rate
= ( Total Pi1 + Total Pi1L * 8 )
/ ( 96 [Cluster] * 76880 )
The "Read command" is issued. *1
Transfer Length = 100h = 8 [Cluster]
The error rate is displayed
on the screen.
The "Recorder Command" is issued.
(Read Error Information)
Error data are obtained.
Pi1 = Number of ErrNumPi1
Pi1L = Number of UePiLine1
Total Pi1 = Total Pi1 + Pi1
Total Pi1L = Total Pi1L + Pi1L
Total Cluster = Total Cluster + 8
C
*1 : The Transfer Length for the Read command in this flowchart is
assumed to be 100h, as an example.
*2 : Number of the total read blocks
96 [Cluster] ∗ 76880 = 96 [Cluster] ∗ 1 ECC Cluster [ 155 columns ∗ 496 rows]
Formula for computation of error rate
• For DVD: See "Error Rate Computation Method for a DVD" .
• For BD: See "Error Rate Computation Method for a BD".
D
Display format of the OSD
1
2
3
4
1 Title & Chapter data: Title No. and Chapter No. of the title being
played back
*For details on title & chapter display, see "Specifications of
Screen Display and FL Display."
2 Playback duration data: Elapsed time of the title being played back
E
3 LgcSct Address data: A logical sector address (Bytes 3-6 of
Request Sense Standard Data [Information]) at the start point of
error rate measurement is displayed.
4 Error rate data: Measured error rate value
* Error rate values are displayed endlessly as far as playback is performed.
F
39
BDP-05FD
5
6
7
8
1
A
2
3
4
ATA/ATAPI DEBUG OSD
Press the ESC, DISP, then 3 keys, in that order, to display the 1st screen for ATA/ATAPI DEBUG OSD.
Then press the DIG/ANA key to switch screens.
• 1st screen (ATA/ATAPI DEBUG OSD-Command history [ALL])
4
1 Packet commands from the host (10 Bytes from the beginning are
displayed.)
2 Error data for the corresponding packet commands in the Status
register
If the error bit is 0: OK
If the error bit is 1: Error code (Sense key, ASC, ASCQ)
3 This indicates the latest command log.
4 The first 9 command logs are listed, in descending order.
If the number of logs exceeds 9, the subsequent log will overwrite the
oldest (uppermost) log, and the same will follow as the logs are added.
2
1
3
B
• 2nd screen (ATA/ATAPI DEBUG OSD-Command history [ERROR])
5
1 The beginning (1 byte) of the packet command that was failed is
indicated.
2 Error code (Sense key, ASC, ASCQ)
3 The command-specific information (4 bytes) that was acquired by the
Request Sense command is displayed.
4 This indicates the latest command log.
5 The first 9 command logs are listed, in descending order.
If the number of logs exceeds 9, the subsequent log will overwrite the
oldest (uppermost) log, and the same will follow as the logs are added.
3
1
2
C
4
The error log for the Test Unit Ready command will not be displayed as
a command log.
• 3rd screen (ATA/ATAPI DEBUG OSD-Drive maintenance data)
1
2
3
4
5
D
1
2
3
4
5
E
Accumulated power-on duration
LD read power-on duration for the BD
LD read power-on duration for the DVD.
LD read power-on duration for the CD.
Serial No. of the PU
The power-on duration and error logs that the writer manages are displayed.
To update the display, press the SEARCH key of the remote control unit for service while this screen is being displayed.
F
40
BDP-05FD
1
2
3
4
5
6
7
8
A
[How to acquire various data]
• Commands for acquiring various durations of the drive
Use the LogSense command.
If "PKT:4D 00 70 00 00 00 00 00 20 00 00 00" is issued, the following data are stored in the Read buffer:
<How to read the data in the Read buffer>
Accumulated power-on duration of the drive : data [8]-[11] (Most Significant Byte: data [8], Least Significant Byte: data [11])
LD read power-on duration for the DVD
: data [12]-[15] (Most Significant Byte: data [12], Least Significant Byte: data [15])
LD read power-on duration for the CD
: data [20]-[23] (Most Significant Byte: data [20], Least Significant Byte: data [23])
LD read power-on duration for the BD
: data [28]-[31] (Most Significant Byte: data [28], Least Significant Byte: data [31])
The unit for accumulated power-on duration is 2 minutes.
The format for duration indication is "hours:minutes."
B
• Commands for acquiring the PU serial No.
Use the "Read Buffer" command.
If "PKT:3c 02 A0 00 ∗∗ ∗∗ 00 00 02 00 00" (∗∗ ∗∗: Read address) is issued, part of the PU serial number can be confirmed
at data [0]/data [1] of the Read buffer. (Most Significant Byte: data [1], Least Significant Byte: data [0])
Enter the following address in the read address (∗∗ ∗∗) to acquire drive serial data:
Most Significant Least Significant
Read address:
0x104,
0x106
Display the acquired serial No. in decimal notation.
[E.g.]
Acquiring data for 0x104:
PKT:3c 02 A0 00 01 04 00 00 02 00 00 00
data[1] = 0x00 , data[0] = 0x01
C
Acquiring data for 0x106:
PKT:3c 02 A0 00 01 06 00 00 02 00 00 00
data[1] = 0x28 , data[0] = 0x7A
PU serial No.: 0x0001287A ––> 00075898
D
• 4th screen (ATA/ATAPI DEBUG OSD-Judgment of degradation of LDs)
E
It is indicated to what extent the LDs (for BD, DVD, and CD) of the drive have degraded. To update the on-screen data,
press the SEARCH key on the remote control unit for service while this screen is displayed. For details on the display
content and updating conditions, see Table 1 below:
Table 1: Display content and updating conditions
Display Item
BD
DVD
Conditions for updating on-screen
data by pressing the SEARCH key
Display Content
Judgment of degradation of the LD for BD.
NG with a rate of 120% or higher
Judgment of degradation of the LD for DVD.
NG with a rate of 120% or higher
No disc in the disc tray
No disc in the disc tray
CD
Judgment of degradation of the LD for CD.
NG with a rate of 120% or higher
No disc in the disc tray
TMP
Current temperature inside the writer
No disc in the disc tray
F
41
BDP-05FD
5
6
7
8
1
A
2
3
4
[How to acquire various data]
• Command for measuring the LD degradation rate
Use the Write Buffer command.
After entering btr[0] = 99 and btr[1] = 50 to the Write Buffer,
issue the "PKT:3b 02 e1 00 00 00 00 00 20 00 00 00" packet command.
• Command for acquiring the LD degradation rate
Use the Read Buffer command.
When the "PKT:3c 02 e1 00 00 00 00 00 20 00 00 00" is issued, the following data are stored in the Read Buffer.
B
<How to read the Read Buffer>
CD degradation rate (%) : data[15]/data[16] (Most Significant Byte: data[15], Least Significant Byte: data[16])
DVD degradation rate (%) : data[3]/data[4]
(Most Significant Byte: data[3], Least Significant Byte: data[4])
BD degradation rate (%) : data[5]/data[6]
(Most Significant Byte: data[5], Least Significant Byte: data[6])
Current temperature
: data[7]/data[8]
(Most Significant Byte: data[7], Least Significant Byte: data[8])
Temperature at the time of CD adjustment : data[17]/data[18] (Most Significant Byte: data[17], Least Significant Byte: data[18])
Temperature at the time of DVD adjustment : data[11]/data[12] (Most Significant Byte: data[11], Least Significant Byte: data[12])
Temperature at the time of BD adjustment : data[13]/data[14] (Most Significant Byte: data[13], Least Significant Byte: data[14])
Temperature (ºC) = Acquired temperature value x 0.25
Example: When the acquired temperature value is 64h: Temperature = 64h x 0.25 = 25 (ºC)
The value for the LD degradation rate is that before correction. Perform temperature correction.
• On temperature correction coefficien
CD 6%/10ºC, DVD 8%/10ºC, BD 10%/10ºC
C
<How to correct the temperature>
BD
1
2
Coefficient A = 1 + Current temperature - Temperature at the time of BD adjustment × 0.1
10
Current temperature: To be acquired with the Read Buffer command (data[7]/data[8] × 0.25)
Temperature at the time of BD adjustment: To be acquired with the Read Buffer command
(data[13]/data[14] × 0.25)
0.1 : BD temperature correction coefficient
1 Degradation rate of the LD for BD = Degradation rate of BD/Coefficient A
Degradation rate of BD: To be acquired with the Read Buffer command (data[5]/data[6])
2 OK/NG indication
OK: When the degradation rate of the LD for BD is less than 120%.
NG: When the degradation rate of the LD for BD is 120% or higher.
D
DVD
Coefficient B = 1 + Current temperature - Temperature at the time of BD adjustment × 0.08
10
3
4
Current temperature: To be acquired with the Read Buffer command (data[7]/data[8] × 0.25)
Temperature at the time of DVD adjustment: To be acquired with the Read Buffer command
(data[11]/data[12] × 0.25)
0.08 : DVD temperature correction coefficient
3 Degradation rate of the LD for DVD = Degradation rate of DVD/Coefficient B
Degradation rate of DVD: To be acquired with the Read Buffer command (data[3]/data[4])
4 OK/NG indication
OK: When the degradation rate of the LD for DVD is less than 120%.
NG: When the degradation rate of the LD for DVD is 120% or higher.
E
CD
Coefficient C = 1 + Current temperature - Temperature at the time of BD adjustment × 0.06
10
5
6
7
F
Current temperature: To be acquired with the Read Buffer command (data[7]/data[8] × 0.25)
Temperature at the time of CD adjustment: To be acquired with the Read Buffer command
(data[17]/data[18] × 0.25)
0.06 : CD temperature correction coefficient
5 Degradation rate of the LD for CD = Degradation rate of CD/Coefficient C
Degradation rate of CD: To be acquired with the Read Buffer command (data[15]/data[16])
6 OK/NG indication
OK: When the degradation rate of the LD for CD is less than 120%.
NG: When the degradation rate of the LD for CD is 120% or higher.
7 Current temperature: To be acquired with the Read Buffer command (data[7]/data[8])
42
BDP-05FD
1
2
3
4
5
6
7
8
A
Indications for the Results of Self-Diagnosis
Self-diagnosis is performed upon startup of the product, and the results are displayed as shown below.
For details on operation and description of the self-diagnosis function, see the specifications of "Self-Diagnosis Function."
• Specifications of indications for the results of self-diagnosis
1
2
3
4
5
B
C
1
2
3
4
5
SKY Chip Info: Version and revision Nos. of the SKY Chip
HDMI Transmitter: Result of checking communications with the SII9134CTU
SUBCON: Result of checking communications with the LC87F5932A
PLL Synthesizer: Result of checking communications with the CDCE906
DRIVE: Result of checking communications with the BD drive
D
E
F
43
BDP-05FD
5
6
7
8
1
2
3
4
7. DISASSEMBLY
A
Note 1: Do NOT look directly into the pickup lens. The laser beam may cause eye injury.
Note 2: Even if the unit shown in the photos and illustrations in this manual may differ from your product, the procedures
described here are common.
Diagnosis of PCB’s
1 Bonnet Case S and Tray Panel
Bonnet case S
1
2
B
Remove the eight screws.
Remove the bonnet case S.
Tray panel
1
2
3
4
5
Press the u STANDBY/ON button to turn on the power.
Press the h OPEN/CLOSE button to open the tray.
Remove the tray panel.
15
Press the h OPEN/CLOSE button to close the tray.
Press the u STANDBY/ON button to turn off the power.
C
3
2
Tray
4
24
Tray panel
D
How to open the tray when the power cannot be turned on
When the tray cannot be opened because the power cannot be turned on, it can be opened using the emergency disc ejection rod
(GGF1529). (A long, thin rod about 1 mm in diameter can be used in place of the rod.)
Tray
DRIVE Assy BDV-103
E
Emergency disc ejection rod
(GGF1529)
F
44
BDP-05FD
1
2
3
4
5
6
7
8
A
2 Front Panel Section
1
2
Remove the four screws.
BDP-05FD
only
Remove the two screws. (BDP-05FD only)
2
1
1
1
1
2
B
MAIN Assy
3
4
Remove the three tapes.
4
C
Disconnect the one flexible cable.
CN4401
3
3
3
D
5
6
Unhook the four hooks.
Remove the front panel Section.
E
6
Front panel Section
5
5
5
5
F
45
BDP-05FD
5
6
7
8
1
A
2
3
4
3 DRIVE Assy BDV-103
1
2
3
4
Remove the ATAB Assy.
Remove the one connector.
ATAB Assy
Release the jumper wires.
Remove the four screws.
2
1
B
C
4
4
3
4
4
3
3
3
D
5
DRIVE Assy BDV-103
Remove DRIVE Assy BDV-103.
E
5
F
46
BDP-05FD
1
2
3
4
5
6
7
8
A
4 Rear Panel
1
2
3
4
5
6
7
Disconnect the two connectors.
DC FAN Motor
Remove the two screws.
MAIN Assy
Remove the two screws.
1
Remove the eight screws.
Remove the one screw.
1
CN1
Remove the three screws.
CN101
Remove the rear panel.
Rear panel
POWER SUPPLY Unit
4
3
×5
3
2
4 4
2
7
4
5
6
6
B
6
Note:
Do not use an electric screwdriver.
If the screw is over-tightened, the screw thread may be damaged.
C
5 AUJB and MAIN Assys
1
2
Remove the two screws.
AUJB Assy
Remove the AUJB Assy.
D
1
1
2
E
MAIN Assy
3
4
5
Remove the five screws.
3
Release the jumper wire.
3
3
Remove the MAIN Assy.
4
5
3
3
F
47
BDP-05FD
5
6
7
8
1
A
2
3
4
6 Diagnosis
1
2
3
Reassembling the DRIVE Assy BDV-103.
Reassembling the front panel Section.
Arrange the unit as shown in the photo below.
Diagnosis
B
AUJB Assy
C
1
DRIVE Assy
BDV-103
2
Front panel Section
D
POWER SUPPLY Unit
(SYPS ASSY)
E
MAIN Assy
F
48
BDP-05FD
1
2
3
4
5
6
7
8
A
Cleaning the Pickup Lens
Writer stay L and R
1
2
Remove the four screws.
Writer stay L
Remove the writer stays L and R.
1
Writer stay R
1
1
Front
2
1
2
B
Front bezel
1
2
Unhook the four hooks.
Remove the front bezel.
C
2
Front bezel
1
1
1
1
D
1
Lower case
1
Upper case
1
Remove the four screws.
E
1
1
Front
Bottom view
49
BDP-05FD
5
6
F
7
8
1
2
3
4
A
2
3
Remove the three screws.
Remove the upper case.
2
Upper case
B
2
2
3
Front
C
1
2
1
1
Clamper
Remove the four screws.
Remove the clamper.
Clamper
2
D
1
1
Front
Before shipment, be sure to clean the pickup lenses,
using the following cleaning materials:
E
Cleaning liquid : GEM1004
Cleaning paper : GED-008
Pickup lenses
F
Front
50
BDP-05FD
1
2
3
4
5
6
7
8
8. EACH SETTING AND ADJUSTMENT
8.1 NECESSARY ADJUSTMENT POINTS
When
Adjustment Points
A
Exchange Parts of Mechanism Assy
Mechanical None
point
Exchange the DRIVE ASSY
Electric
point
ID NUMBER and DATA SETTING
FIRMWARE UPDATE
B
Exchange PCB Assy
Mechanical None
point
Exchange MAIN ASSY
Electric
point
MODEL SETTING
ID NUMBER and DATA SETTING
FIRMWARE UPDATE
C
D
E
F
51
BDP-05FD
5
6
7
8
1
2
3
4
8.2 MODEL SETTING
Destination Setting Screen
A
B
Fig. 1: Screen image 1
C
• The screen for setting the destination region will be analogous to the screen shown in Fig. 1.
• A proportional font will be used.
• Entering a 4-digit number is possible with the remote control unit for service (Fig. 2).
• To shift to the next page, the SIDE-B key is used. When this key is pressed while the last page is displayed,
Page 1 will be displayed.
• To shift to the previous page, the SIDE-A key is used. When this key is pressed while Page 1 is being displayed,
the last page will be displayed.
The input numbers and model names will be changed when pages are changed (Fig. 3).
Other indications and operations are common to all pages.
• If there are several pages, any destination number will be accepted regardless of the currently displayed page.
• To exit the Destination Setting screen, press the ESC key.
• On input keys
Key
Operation
Keys 0-9 on the remote control unit for service
For inputting numerics.
CLEAR key on the remote control unit for service For canceling input numerics and returning to the initial display.
Keys other than those mentioned above will not be accepted.
D
• Once all 4 digits are input, that number is set.
-> If a number corresponding to the input number does not exist, the error message will be displayed. (Fig. 4)
-> After the error message is displayed, no key input will be accepted. (Unplug the power cord.)
• The first input numeric is displayed at the rightmost position then will be shifted to the left with subsequent key inputs,
as shown below:
No input
A "1" is input. (Even if a nonvalid numeric is input, the error message will not be displayed at this stage.)
A "2" is input. (Even if a nonvalid numeric is input, the error message will not be displayed at this stage.)
When the CLEAR key is pressed, the screen will return to the initial display.
E
A "3" is input. (Even if a nonvalid numeric is input, the error message will not be displayed at this stage.)
When the CLEAR key is pressed, the screen will return to the initial display.
A "4" is input. (If the input 4-digit number is not a valid number, "> 1234" is instantly [0.2 sec] displayed.
Then an error message will be displayed.)
When the CLEAR key is pressed, the screen will return to the initial display.
The above "> 1234" is instantly (0.2 sec) displayed
then the Model Setting screen will be cleared.
F
• To correct the input data, press the CLEAR key on the remote control unit for service.
All the input numerics will be cleared.
52
BDP-05FD
1
2
3
4
5
6
7
8
• On the model indications
• The model number then the destination are indicated in the Model column.
• A full model number is indicated (16 one-byte characters at maximum).
• The model numbers and destinations are displayed in alphabetical and ascending numeric orders, from the top line
in the left column.
A
• If the corresponding number exists:
-> The model and region numbers are displayed for 2 sec. (Fig. 5)
-> Then the unit will be turned off.
• FL display
While the Model Setting screen is displayed:
B
If the input model number exists:
(After this indication is displayed for 2 sec, the unit is turned off.)
If the input model number does not exist:
C
Fig. 2: Screen image 2
D
Fig. 3: Screen image 3
E
Fig. 4: Screen image 4
F
Fig. 5: Screen image 5
53
BDP-05FD
5
6
7
8
1
2
3
4
8.3 CPRM ID NUMBER AND DATA SETTING
[Purposes]
A
An individual ID number and ID data (AACS, CPRM, BD+, Windows Media DRM, and MAC address)
must be input at the same time. All data are determined according to the data on the ID data disc. If the
number and data are not set correctly with the following procedure, the unit does not work properly.
You will find the ID number to be labeled on the rear panel.
This setting is Necessary When:
When the DRIVE Assy or MAIN Assy is replaced.
B
[Tools to be used]
Remote control unit for servicing
(GGF1067)
C
ID Disc for Blu-ray Player Type 2 Vol 1.0
(GGV1324)
Important: If no ID label is found on the rear panel, write down the specified ID number by checking it
on the version check screen ([ESC] + [DISP]).
[Notes]
Input the ID number while the unit is in Stop mode.
After the data are read from the ID data disc, the disc will automatically be unloaded.
Each time a key input succeeds, the screen background becomes blue. If a key input fails, the screen
background becomes red.
D
E
F
54
BDP-05FD
1
2
3
4
5
6
7
8
CPRM ID Registration Mode
A
• Conditions for entering CPRM ID Registration mode
During Playback Stop mode, press the ESC then STEREO
keys.
The above key inputs are accepted only during Normal
Playback Stop mode.
5 During data reading, the indications below will be
displayed. ("LOAD ID DATA" is displayed on the FL
display.)
• Conditions for exiting CPRM ID Registration mode
Press the CLEAR key to return to Normal mode.
• How to input the ID No. and ID data
1 To enter Input mode, press the ESC then STEREO keys.
2 After entering Input mode, input a 9-digit ID No.
(The number is displayed on the FL display.)
The ID No. is described on the ID label located on the
rear panel of the product.
5
B
6 After reading of the ID data is completed, writing of the
data on the flash ROM will start. ("WRITE ID DATA" is
displayed on the FL display.)
2
6
C
7 Upon completion of writing on the flash ROM, "Rom
Write OK!" will be displayed. ("ID DATA OK" will be
displayed on the FL display.)
The background color of the screen will change to blue
when writing of various key data is successfully
completed. If writing fails, the background color will
change to red.
3 After the 9-digit ID No. is input, the SEARCH key will be
accepted. If it is pressed, the ID No. will be displayed.
3
8 Upon completion of writing, press the CLEAR key to exit
Input mode.
D
When writing is successfully completed
4 After the ID No. is set, the unit awaits ID data input.
("INSERT ID DATA" is displayed on the FL display.)
Load the ID data disc in the disc tray. As soon as the tray
is closed, reading of the data will start.
7
8
E
When writing fails
4
F
55
BDP-05FD
5
6
7
8
1
2
3
4
3
4
CPRM ID Registration Mode 2
A
• How to clear the ID No.
1 With the ID No. set, press the ESC then STEREO keys.
2 Input the same number as the set ID No.
2
B
3 Press the STOP key after the 9-digit number is input.
Only when the input number and the set number
coincide, the set ID No. will be erased, and the unit will
exit this mode.
If the numbers do not coincide, the screen will return to
that in Step 2.
(The STOP key is not accepted after input of a 9-digit
number is finished.)
C
3
D
• Example of the FL display during numeric input for
the ID No.
When the numerics 0, 1, and 2 are input, in that order:
[
012]
* If an ID No. is already registered, the registered ID No. is
displayed before you enter any numeric. (The registered
ID No. also remains displayed when a wrong ID No. is
input [NG].)
Before any numeric is input (registered ID: 012345678)
[012345678]
When the first digit (0) is input
[
0]
E
F
56
BDP-05FD
1
2
5
6
7
8
8.4 FIRMWARE UPDATE
A
UPDATE PROCEDURE
1.
Plug a power cable into the unit.
2. Press the "STANDBY/ON" button to switch the unit on.
3. Press the "OPEN/CLOSE" button to open the disctray.
4.
Place an UPDATE disc on the tray.
5.
Press the "OPEN/CLOSE" button on the front panel to begin the application update.
* FL display indicates "DL OK" and the unitauto matically switches into standby with the tray
opening.
B
* The update time takes 5 to 25 minutes, it changes depending on the version.
DO NOT unplug the power cable or press the standby button until
the unit switches into standby mode.
C
6.
Remove the UPDATE disc from the tray.
7.
Press the "STANDBY/ON" button to switch the unit on, and check if FL display indicates "DL OK".
The updato is completed if FL display indicatates "DL OK".
D
E
F
57
BDP-05FD
5
6
7
8
1
2
3
4
9. EXPLODED VIEWS AND PARTS LIST
NOTES:
Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- Screws adjacent to b mark on product are used for disassembly.
- For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
-
A
9.1 PACKING SECTION
B
C
BDP-05FD Only
D
E
F
58
BDP-05FD
1
2
3
4
5
6
7
8
(1) PACKING SECTION PARTS LIST
Mark No.
>
Description
Part No.
1
Power Cable
ADG7061
2
Audio Cable (white/red plugs)
VDE1064
3
Video Cable (Yellow plugs)
VDE1065
4
Remote Control
See Contrast table (2)
5
Battery Cover
VZN1025
Dry Cell Battery (R6, AA)
AEX1025
NSP 6
7
A
Operating Instructions (English) See Contrast table (2)
NSP 8
Warranty Card
See Contrast table (2)
NSP 9
Update Guide (Paper)
VRY1171
10
User Card
ARY1176
11
Polyethylene Bag
VHL1051
NSP 12
Polyethylene Bag
Z21-038
Front Pad (PS)
VHA1439
13
B
14
Rear Pad (PS)
VHA1440
15
Packing Case (Paper)
See Contrast table (2)
16
Mirror Sheet
VHL1006
17
Nonwoven Cloth Cover
See Contrast table (2)
Serial Label S
VRW2017
NSP 18
C
(2) CONTRAST TABLE
BDP-05FD/KU/CA and BDP-51FD/KU/CA are constructed the same except for the following:
Mark No.
NSP
4
7
8
15
17
Symbol and Description
Remote Control
Operating Instructions (English)
Warranty Card
Packing Case (Paper)
Nonwoven Cloth Cover
BDP-05FD
/KU/CA
BDP-51FD
/KU/CA
VXX3313
VRB1502
ARY1026
VHG2878
VHL1129
VXX3333
VRB1505
ARY7045
VHG2881
Not used
D
E
F
59
BDP-05FD
5
6
7
8
1
2
3
4
9.2 EXTERIOR SECTION
A
SERVICE MAIN Assy
MAIN Assy (BDP2.0)
ATAB Assy (BDP2.0)
B
B
D
F
D
C
A
E
C
D
E
G
B
A
C
D
F
BDP-05FD
Only
E
BDP-05FD
Only
F
Refer to
“9.3 FRONT PANEL SECTION”.
60
BDP-05FD
1
2
3
4
CONTACT SIDE
NON-CONTACT
SIDE
A
5
6
7
8
(1) EXTERIOR SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
Description
Part No.
See Contrast table (2)
NSP 26
Binder (BK-1)
ZCA-BK1
NSP 2
2..MAIN Assy (BDP2.0)
See Contrast table (2)
27
Tray Sheet (EPDM)
VEC2593
3
2..ATAB Assy (BDP2.0)
VWV2360
28
Tray Panel IPO (ABS)
See Contrast table (2)
1
1..SERVICE MAIN Assy
29
Gasket 10 * 15T (PLA)
VEC2608
ID Label Assy
VXW1021
Tape
ZTA-156A-19
A
NSP 4
AUJB Assy
See Contrast table (2)
>
5
SYPS ASSY
VWR1415
NSP 30
6
DRIVE Assy BDV-103-XP/5
VXX3325
NSP 31
7
AC Inlet Assy
ADX7723
32
•••••
8
Connector Assy
PF11PP6D25
33
•••••
9
Connector Assy
PF13PP-D32
34
CSM Screw C 4 x 6 (B)
ABA7137
10
Flexible Cable (40 PIN)
VDA2182
35
Screw (FE)
See Contrast table (2)
11
Flexible Cable 27P
VDA2183
36
Screw
AMZ30P060FTC
12
Housing Assy (4P)
VKP2408
37
Screw
See Contrast table (2)
13
DC FAN Motor
VXM1122
38
Screw
BBZ30P060FTC
14
Thermal Sheet B
AEB1417
39
Screw
See Contrast table (2)
15
Insulator
See Contrast table (2)
40
Screw
See Contrast table (2)
See Contrast table (2)
>
16
NSP 17
Heatsink B
ANH1645
41
Screw
Base Chassis IPO (FE)
VNA3068
42
Screw
IBZ30P060FCC
Bonnet Case S
VXX3324
Screw
Screw
See Contrast table (2)
See Contrast table (2)
Screw
See Contrast table (2)
Rear Panel IPO (FE)
See Contrast table (2)
43
44
Writer Stay L IPO (FE)
VNE2499
45
NSP 21
Writer Stay R IPO (FE)
VNE2500
46
NSP 22
Front Stay IPO (FE)
VNE2501
NSP 23
PCB Stay IPO (FE)
VNE2502
NSP 24
Rear Stay IPO (FE)
VNE2503
Cord Clip
VNX1026
18
19
NSP 20
25
B
C
Serial Label S
VRW2017
D
(2) CONTRAST TABLE
BDP-05FD/KU/CA and BDP-51FD/KU/CA are constructed the same except for the following:
Mark No.
NSP
NSP
Symbol and Description
BDP-05FD
/KU/CA
BDP-51FD
/KU/CA
1
2
4
15
19
SERVICE MAIN Assy
MAIN Assy (BDP2.0)
AUJB Assy
Insulator
Rear Panel IPO (FE)
VXX3326
VWV2315
VWG2615
AMR7198
VNA3070
VXX3328
VWV2375
VWG2632
PNW2766
VNA3075
28
35
37
39
40
Tray Panel IPO (ABS)
Screw (FE)
Screw
Screw
Screw
VNK6407
YBA1001
BBZ30P060FCC
BPZ30P080FCC
CBZ30P080FCC
VNK6408
VBA1088
BBZ30P060FTB
BPZ30P080FTC
CBZ30P080FTC
41
43
44
45
Screw
Screw
Screw
Screw
IBP30P090FCC
BBZ30P060FCC
IBZ30P060FCC
IBZ30P060FCC
BBZ30P060FTB
BBZ30P060FTC
BBZ30P060FTB
BBZ30P060FTC
E
F
61
BDP-05FD
5
6
7
8
1
2
3
4
9.3 FRONT PANEL SECTION
A
C
B
BDP-05FD Only
B
BDP-05FD Only
F
MAIN
CN4401
C
for BDP-51FD
BDP-51FD Only
BDP-05FD Only
BDP-05FD
Only
D
to
Chassis
F
62
BDP-05FD
1
2
3
4
CONTACT SIDE
NON-CONTACT
SIDE
E
5
6
7
8
(1) FRONT PANEL SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
FLKY Assy
See Contrast table (2)
17
Key Lens IPO (ABS)
VNK6417
2
PSWB Assy
VWG2613
18
IB Lens V5SEL IPO (PL)
See Contrast table (2)
3
CAPK Assy
See Contrast table (2)
19
PCB Mould HQ IPO (PLS)
See Contrast table (2)
20
Panel Base Assy IPO
See Contrast table (2)
21
MAIN Key IPO (ABS)
See Contrast table (2)
Energy Star Label
AAX8022
NSP 4
Cord with Plug
See Contrast table (2)
5
Flexible Cable 30P
VDA2185
6
Flexible Cable 5P
VDA2186
7
Flexible Cable 5P
See Contrast table (2)
23
•••••
8
Earth Plate Cap (CU)
See Contrast table (2)
24
•••••
9
Earth Plate AL IPO
See Contrast table (2)
25
Screw
10
AL Panel IPO (AL)
See Contrast table (2)
26
Screw
See Contrast table (2)
11
Pioneer Badge G (AL)
See Contrast table (2)
27
SPACER PB (PET)
See Contrast table (2)
12
FL Filter IPO (IPO)
See Contrast table (2)
28
FIBER WASHER
See Contrast table (2)
13
Key Top PW (ABS)
VNK6380
NSP 22
14
Key Top PL (ABS)
VNK6381
15
Ring (ABS)
See Contrast table (2)
16
Key Base PW/PL IPO
VNK6412
A
BPZ30P080FBN
B
C
(2) CONTRAST TABLE
BDP-05FD/KU/CA and BDP-51FD/KU/CA are constructed the same except for the following:
Mark No.
NSP
1
3
4
7
8
Symbol and Description
FLKY Assy
CAPK Assy
Cord with Plug
Flexible Cable 5P
Earth Plate Cap (CU)
BDP-05FD
/KU/CA
BDP-51FD
/KU/CA
VWG2612
VWG2614
DE007VC0
VDA2186
VBK1189
VWG2625
Not used
Not used
Not used
Not used
D
9
10
10
11
11
Earth Plate AL IPO
AL Panel IPO (AL)
Front Cover IPO (ABS)
Pioneer Badge G (AL)
Name Plate B NEW (AL)
VBK1190
VAH1464
Not used
VAM1159
Not used
Not used
Not used
VNK6418
Not used
AAN7218
12
12
15
18
19
FL Filter IPO (IPO)
FL Filter IPO (PC)
Ring (ABS)
IB Lens V5SEL IPO (PL)
PCB Mould HQ IPO (PLS)
VEC2605
Not used
VNK6382
VNK6440
VNK6441
Not used
VEC2606
Not used
Not used
Not used
20
21
26
27
28
Panel Base Assy IPO
MAIN Key IPO (ABS)
Screw
SPACER PB (PET)
FIBER WASHER
VXA2955
Not used
Not used
Not used
Not used
VXA2958
VNK6420
BPZ26P060FTC
VEC2633
VEC2634
E
F
63
BDP-05FD
5
6
7
8
1
2
3
4
5
6
7
8
9
V+3E
C1601
1u/10
R1601
220
R1602
220
R1605
220
R1606
220
R1610
220
SCON_RXD
R1621
NM
R1624
NM
SCON_TXD
220
R1652
R1611
220
C1621
NM
1
2
INB
IC1621
NM
R1622
220
VCC
OUTY
SCIFRTS
SCIFSCK
SCIFCTS
5
4
R1609
22
SPDIF_ON
10k
R1239
M32_UARTRTS
M32_UARTCTS
SH_UART1RXD
R1623
22
V+3D
22
V+3D
SCIFSCK
SCIFCTS
SCIFRTS
SCIFTXD
SH_UART1TXD
R1129
HDMI/DVI#
R1126100
ADAC_MUTE
V+3D
R1248
10k
R1247
10k
R1245
10k
10k
R1246
SRXD1
STXD1
V+3D
10k
ETHER
SCLK0
STXD0
SCLK1
22
22
A14
SH_GPIO4(7)
A15
SH_GPIO3(3)
A16
SH_GPIO3(6)
A17
STXD0
A18
SCIFTXD
SCIFRXD
B13
SH_GPIO4(1)
B14
SH_GPIO4(5)
B15
SH_GPIO3(1)
B16
SH_GPIO3(5)
B17
SRXD0
B18
SCIFRTS
SH_GPIO2(3)
C12
SH_GPIO6(3)
C13
SH_GPIO6(7)
C14
SH_GPIO4(3)
C15
SH_GPIO3(0)
C16
SH_GPIO3(4)
C17
SH_GPIO3(7)
C18
SCLK0
VDD33_2
D12
SH_GPIO0(4)
D13
SH_GPIO7(6)
D14
SH_GPIO6(4)
D15
SH_GPIO4(4)
D16
SH_GPIO3(2)
D17
SCIFCTS
D18
SH_GPIO2(4)
VDD33_3
E11
M32_GPIO(0)
E12
SH_GPIO7(0)
E13
VSS11
E14
SH_GPIO4(0)
E15
SH_GPIO4(6)
E16
VSS12
E17
SRDY0
E18
SCIFSCK
VDD33_4
F11
VDD33_8
F12
VSS21
F13
VSS22
F14
VDD33_9
F15
VDD33_10
F16
VSS23
F17
VSS24
F18
VSS25
VDD33_11
ADV_SDA1
ADV_SCL1
SRDY0
SRXD0
A13
SH_GPIO4(2)
B12
SH_GPIO6(5)
D11
SH_GPIO0(0)
10k
0
22
22
22
22
A12
SH_GPIO6(6)
C11
SH_GPIO0(2)
R1249
R1251
R1115
R1112
R1113
R1114
22
B11
SH_GPIO6(1)
SRDY1
R1116
A11
SH_GPIO6(2)
R1111
R1127
R1128
R1107
R1108
R1109
22
22
22
22
22
22
R1105
22
ETX_CLK
ETXD0
ERXD0
ECOL
ERX_CLK
R1117
22
22
F10
VDD33_7
GND
ETX_EN
R1118
E10
VSS10
ADAC_MDO
ADAC_CS1
ADAC_CS2
ADAC_MDC
ETXD1
ETXD3
ETXD2
ERXD6
D10
M32_GPIO(1)
C1014
0.1u
C1091
VCG1063-A
C1015
VCG1063-A
C1016
1u
VCG1063-A
C1017
C1018
0.1u
F9
VSS20
C10
SH_GPIO6(0)
E9
SH_GPIO5(5)
F8
VSS19
B10
SH_GPIO0(5)
D9
SH_GPIO5(3)
E8
SH_GPIO1(4)
F7
VDD33_6
G6
VSS33
A10
SH_GPIO0(3)
C9
SH_GPIO7(4)
D8
SH_GPIO2(7)
E7
VSS9
F6
VDD33_5
G5
HADRS(17)
22
B9
SH_GPIO7(5)
C8
SH_GPIO0(1)
D7
M32_GPIO(7)
E6
SH_GPIO5(7)
F5
VSS18
G4
HADRS(15)
R1120
A9
SH_GPIO7(7)
B8
ERXD(4)
C7
SH_GPIO7(1)
D6
M32_GPIO(6)
E5
SH_GPIO2(5)
F4
HADRS(21)
G3
HADRS(5)
R1119
22
A8
SH_GPIO7(3)
B7
SH_GPIO7(2)
C6
M32_GPIO(3)
D5
SH_GPIO5(1)
E4
HADRS(24)
F3
HADRS(11)
G2
SH_GPIO1(2)
ETXD6
ETXD7
A7
ELNKST
B6
M32_GPIO(5)
C5
M32_GPIO(2)
D4
SH_GPIO1(6)
E3
HADRS(23)
F2
HADRS(4)
ETX_ER
A6
SH_GPIO2(2)
B5
SH_GPIO5(4)
C4
SH_GPIO5(0)
D3
HADRS(20)
E2
HADRS(12)
22
A5
M32_GPIO(4)
B4
SH_GPIO2(6)
C3
HADRS(8)
D2
HADRS(26)
R1121
A4
SH_GPIO5(6)
B3
SH_GPIO5(2)
C2
HADRS(18)
ERX_DV
A3
SH_GPIO1(7)
B2
NMI
R1122
22
R1123
22
R1124
22
NM
22
22
R1125
R1131
R1135
22
R1133
GND
A2
SH_GPIO2(1)
ERXD2
ERXD1
ERXD3
ERXD5
ERXD4
ERXD7
ERX_ER
ECRS
EMDC
EMDIO
HDMI_RESET
HDMI_SWING
M32_UARTCTS
M32_UARTRXD
M32_UARTRTS
M32_UARTTXD
XYCBCRMUTE
XSVMUTE
A 6/10
22
22
A 7/10
R1236
10k
IRQ4
R1226
R1227
R1233
R1224
R1225
4.7k
R1228
R1106
22
GND
SH_UART1RTS
SH_UART1CTS
M32IMRQ0_HDMI
SCON_SCL0
SCON_SDA0
V+3D
10k
R1232
10k
R1223
M32IMRQ1_LAN
IRQ5
IRQ3
10k
R1241
GND
R1242
10k
HDMI_SDA2
HDMI_SCL2
SCON_RQI
SCON_RQO
10k
10k
INA
GND
SH_UART1CTS
SH_UART1RTS
M32_UARTTXD
M32_UARTRXD
3
R1243
10k
R1244
10k
A 5/10
V+3D
R1134
4.7k
A 5/10
R1222
10k
3
GND
SCIFRXD
SCIFTXD
SCIFRX
SH_UART1TXD
SH Debug
KN1001
GND
R1235
H6
VDD33_12
H5
HADRS(10)
H4
HADRS(6)
H3
HADRS(2)
H2
SH_GPIO1(1)
J4
HADRS(0)
J5
VSS37
J6
VDD33_13
K4
HADRS(19)
K5
HADRS(25)
K6
VSS38
H
H
H
H
K3
SH_GPIO1(0)
K2
HDATA(1)
J3
HCS_N(0)
J2
WE_N0
H
4
3
10
GND
220
1
4
CLOCK_SEL
R1136
10k
K1
HDATA(4)
BDP-05FD
64
C1020
VCG1063-A
J1
HDATA(0)
HADRS13
HADRS7
HDATA3
HDATA5
HDATA7
A 7/10
ETHER
A 4/10
H1
WE_N1
10k
C1019
1u
SH bus
HADRS10
HADRS6
HADRS2
HCS_N1
WE_N1
10k
HADRS17
HADRS15
HADRS5
HCS_N2
HCS_N3
R1219
IRQ2
10k
10k
HADRS25
HADRS19
WAIT_N
HDATA1
HDATA4
R1220
HADRS21
HADRS11
HADRS4
HADRS3
R1218
R1234
R1237
HCS_N4
G1
SH_GPIO1(3)
MRES_N
F1
HADRS(3)
HADRS8
HADRS18
HADRS22
E1
HADRS(9)
HADRS16
D1
HADRS(14)
RB_N
C1
HADRS(22)
E
B1
HADRS(16)
10k
A1
SH_GPIO1(5)
R1216
R1137
A 10/10
C1211
18p/50
R1229
V+3D
SH_BUS
2
GND
10k
A 4/10
10k
D
R1654
10k
C1654
100p/50
A 5/10
R1651
GND
R1653
10k
C1653
100p/50
A 4/10,5/10
1/2
C1209
18p/50
SCIFTX
NM
2/2
10k
R1231
V+3S
10k
HADRS0
HCS_N0
WE_N0
HDATA0
F
HADRS24
HADRS23
HADRS12
HADRS9
R1217
22
R1215
WP_N
HCS_N6
HADRS20
HADRS26
HADRS14
2
1
11
1/2
R1603
10k
C1603
100p/50
R1604
NM
C1604
100p/50
R1607
10k
C1607
100p/50
R1608
10k
C1608
100p/50
R1612
10k
C1609
100p/50
R1613
10k
C1610
100p/50
GND
C
CN1601
MAIN ASSY
A 1/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
Large size
SCH diagram
4
3
2
1
10. SCHEMATIC DIAGRAM
10.1 MAIN ASSY (1/10)
A
RKN1052-A
B
HCS_N5
22
R1508
22
R1507
82
R1506
33
R1501
82
C1501
100p/50
R1509
1
2
3
4
R1502
33
22
GND
RESET#
DD7
DD8
5
6
33
R1503
R1510
40
39
38
37
DD5
DD9
DD6
7
8
9
10
11
12
R1504
33
R1505
33
NM
R1514
NM
R1515
NM
R1516
R1517
NM
AT1DATA5
AT1DATA9
AT1DATA6
AT1DATA8
AT1DATA7
AT1DATA4
AT1DATA10
AT1DATA5
AT1DATA9
AT1DATA6
AT1DATA8
AT1DATA7
AT1RESET
AT1DATA4
AT1DATA10
AT1DATA2
AT1DATA12
AT1DATA11
AT1DATA13
AT1DATA3
AT1DATA12
AT1DATA1
AT1DATA3
AT1DATA2
AT1DATA11
AT1DATA1
AT1DATA14
AT1DATA13
AT1DATA0
AT1DATA15
AT1DATA0
AT1DATA14
AT1ADR1
AT1DMACK
AT1DIOR
AT1DIOW
AT1IORDY
AT1DATA15
AT1DMARQ
AT1DIOW
AT1DIOR
AT1IORDY
AT1DMACK
AT1ADR1
AT1INTRQ
AT1CS1
AT1CS0
AT1ADR2
AT1ADR0
AT1CS0
AT1ADR0
AT1CS1
R1623
22
VKN1816-A
NM
Audio_control
ADAC_CS1
ADAC_CS2
R1245
10k
10k
R1246
SCLK0
STXD0
SCLK1
DAS1CLK0N
DAS1CLK0
DAS1WE_N
DAS1BA1
DAS1A6
DAS1BA0
DAS1BA2
DAS1A4
DAS1A11
DAS1A13
DA1DQ5
DA1DQ2
DA1DQ3
DA1DQ0
DA1DQ7
DA1DQ1
DA1DQ4
DA1DQM0
DA1DQ6
DA1DQS_N0
DA1DQS0
DA1DQ12
DA1DQ8
DA1DQ9
DA1DQ14
DA1DQ10
DA1DQ15
DA1DQ11
DA1DQM1
DA1DQS1
DA1DQS_N1
DA1DQ13
XAMUTE
XMMUTE
R1249
0
10k
22
22
SRDY0
SRXD0
R1101
R1102
R1104
10k
R1251
GND
R1103
10k
SRDY1
A33
VSS1
A32
DA1CLK0N
A31
DA1CLK0
A30
DA1BA(1)
A29
DA1A(6)
A28
DA1A(13)
A27
DA1DQ(3)
A26
VDD18_3
A25
DA1DQ(6)
A24
VDD18_2
A23
DA1DQ(14)
A22
VDD18_1
A21
DA1DQS_N(1)
A20
VDD33_1
A19
SCIFRXD
A18
SCIFTXD
A17
STXD0
B33
DA1CLK1N
B32
VSS2
B31
VDD18_6
B30
DA1WE_N
B29
VDD18_5
B28
DA1A(11)
B27
DA1DQ(2)
B26
DA1DQ(1)
B25
DA1DQM(0)
B24
DA1DQ(12)
B23
DA1DQ(9)
B22
DA1DQ(11)
B21
DA1DQS(1)
B20
VDD18_4
B19
SH_GPIO2(3)
B18
SCIFRTS
B17
SRXD0
D33
DA1ODT
D32
VDD18_10
D31
DA1CKE
D30
VSS8
D29
VDD18_9
D28
DA1BA(2)
D27
DA1DQ(5)
D26
DA1DQ(0)
D25
DA1DQ(4)
D24
DA1DQS_N(0)
D23
DA1DQ(8)
D22
DA1DQ(10)
D21
DA1DQM(1)
D20
DA1DQ(13)
D19
VDD33_3
D18
SH_GPIO2(4)
D17
SCIFCTS
E28
VDD18_15
E29
VSS17
E30
DA1A(1)
E31
DA1A(2)
E32
DA1CAS_N
E33
DA1CS_N
F27
VDD18_18
F28
VSS30
F29
VSS31
F30
DA1A(7)
F31
VSS32
F32
DA1A(5)
F33
DA1A(9)
G28
VDD18_19
G29
VDD18_20
G30
DA1A(10)
G31
DA1A(3)
G32
DA1A(8)
G33
DA1A(12)
F22
VSS27 C1011
0.1u
C1012
F23
DA1VREF(0)
0.1u
C1090
H33
VDD18_21
H32
DA1DQ(21)
H31
VSS36
H30
DA1A(0)
H29
VSS35
H28
VSS34
C1008
F24
VSS28 VCG1063-A
C1010 C1058
0.1u VCG1063-A
C1009
1u
F25
VDD18_17
F26
VSS29 C1006
VCG1063-A
C1007
0.1u
E27
VDD18_14
E26
VSS16
E25
VDD18_13
E24
VSS15
E23
VDD18_12
E22
VSS14
E17
SRDY0
E18
SCIFSCK
E19
VDD33_4
E20
VSS13
F16
VSS23
F17
VSS24
F18
VSS25
F19
VDD33_11
F20
VSS26
C1091
VCG1063-A
C1014
0.1u
C1013
VCG1063-A
VCG1063-A
F21
VDD18_16
E16
VSS12
E21
VDD18_11
DA1DQ21
DDR2 ch1 2memory
C33
DA1CLK1
C32
DA1RAS_N
C31
VSS7
C30
VDD18_8
C29
DA1BA(0)
C28
DA1A(4)
C27
VSS6
C26
DA1DQ(7)
C25
VSS5
C24
DA1DQS(0)
C23
VSS4
C22
DA1DQ(15)
C21
VSS3
C20
VDD18_7
C19
VDD33_2
C18
SCLK0
C17
SH_GPIO3(7)
D16
SH GPIO3(2)
DAS1A5
DAS1A9
V+3D
GND
V+3D
R1238
10k
22
V+3D
HDMI/DVI#
R1126100
DA1CLK1
C16
SH GPIO3(4)
DAS1A7
DAS1A10
DAS1A3
DAS1A8
DAS1A12
E
DAS1RAS_N
B16
SH GPIO3(5)
PATA
DAS1CKE
DAS1A1
DAS1A2
DAS1CAS_N
DAS1CS_N
R1551
R1553
22k
R1554
22k
R1555
22k
R1558
NM
R1557
NM
10k
R1130
R1591
V+3D
SCIFRXD
SCIFSCK
SCIFCTS
SCIFRTS
SCIFTXD
SH_UART1TXD
R1129
R1552
22k
1k
R1556
SH_UART1RXD
AT1ADR2
AT1INTRQ
AT1DMARQ
5
AT1DATA7
VCC
4
A16
SH GPIO3(6)
J33
DA1DQ(23)
J32
DA1DQ(16)
J31
DA1DQ(17)
J30
DA1DQ(19)
J29
VDD18_23
J28
VDD18_22
V+1R8S
K31
VSS41
K32
DA1DQ(18)
K33
VDD18_24
D
D
DA
V
D
V+3S
K28
VSS39
K29
VSS40
K30
DA1DQ(22)
C1003
35
DD4
DD10
DD11
DD3
DD12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
C1502
47p/50
R1518
NM
IC1621
NM
OUTY
R1248
10k
GND
C1001
36
34
33
32
31
30
29
DD2
DD14
DD1
DD13
DD0
GND
DD15
KEYPIN
DMARQ
GND
GND
DIOW#
DIOR#
GND
IORDY
CSEL
GND
DMACK#
INTRQ
DA1
RESERVED
34
35
36
37
38
39
40
R1511
1
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
DA0
PDIAG#
DA2
CS1#
CS0#
GND
DASP#
33
R1512
82
3
17
2
19
4
21
5
18
23
6
20
25
7
22
27
9
24
29
8
26
31
10
28
33
11
30
12
32
35
15
34
37
13
36
39
14
38
GNDI
7
6
5
4
3
2
5.6k
R1521
10k
R1522
NM
R1523
INB
INA
C1592
ADAC_MUTE
D
A 10/10
SRXD1
STXD1
DA1DQ22
DA1DQM2
DA1DQ20
DA1DQS2
DA1DQS N2
V
VCG1063-A
DAS1ODT
0
C1591
1u/10
R1247
10k
DA1DQ18
C1002
0.1u
16
40
CN9003
F
DAS1A0
DA1DQ19
DA1DQ17
DA1DQ16
DA1DQ23
VCG1063-A
8
7
6
5
1
CN9002
ATAB ASSY
(VWV2360)
ATAB
8
7
6
5
C
GND
1000p
R1106
22
AUDIO
1
GND
R1520
NM
V+3D
1
2
3
GND
A 5/10
1222
10k
NM
2
SCON_RXD
C1621
NM
33
R1513
" angle ="0.000" nsoffset ="0.000in">
A
to DRIVE
B
CN9001
VKN1818-A
CN1501
VKN2050-A
DA1CLK1_N
65
BDP-05FD
2
F1401
DTL1106-A
3
1
GND
GND
4.7k
R1333
4.7k
R1334
4.7k
R1335
4.7k
R1336
4.7k
R1337
4.7k
0
R1401
GND
SDPXCLK
SDPXDATA6
SDPXDATA5
SDPXDATA4
SDPXDATA3
SDPXDATA2
SDPXDATA1
SDPXDATA0
3
47
SDPXWE
SDPXHS
SDPXVS
SHGPIO7
SHGPIO6
SHGPIO5
SHGPIO4
SHGPIO3
SHGPIO2
SHGPIO1
SHGPIO0
DDR2_ch0
2
*R1192
47
R1193
47
R1194
47
DA0DQ13
DA0DQM1
DA0DQS1
DA0DQS_N1
DA0DQ10
DA0DQ15
DA0DQ11
DA0DQ8
DA0DQ9
DA0DQ14
V+3VA
1
AN12
VDD18_64
DA0DQS_N0
DA0DQS0
DA0DQ12
DTL1106-A
*F1421
V+1R8D
DTL1106-A
F1431
GND
AM12
DA0DQ(11)
AN11
DA0DQ(14)
DA0DQ4
DA0DQM0
DA0DQ6
DA0DQ0
DA0DQ7
DA0DQ1
DA0DQ5
DA0DQ2
DA0DQ3
DAS0BA2
DAS0A4
DAS0A11
DAS0A13
DAS0BA0
DAS0A6
DAS0WE_N
DAS0BA1
DAS0CLK0
V+1R1D
0
0
0
3
AL12
DA0DQ(15)
AM11
DA0DQ(9)
AN10
VDD18_63
AG6
VDD18_46
AN4
DA0BA(1)
DAS0CLK0N
R1443
R1444
2
*R1190
47
AK12
DA0DQ(10)
AL11
VSS179
AM10
DA0DQ(12)
AN9
DA0DQ(6)
AF6
VSS153
AM4
DA0WE_N
AN3
DA0CLK0
V+3D
R1445
1
SDPXDO(7)
*R1191
47
PXDO(0)
AN18
SDPXDO(3)
PXDO(1)
AM18
SDPXDO(4)
PXDO(2)
AL18
SDPXDO(5)
PXDO(10)
AK18
SDPXDO(6)
VDD33_26
AJ18
SDPXDO(2)
VDD10_45
AH18
VSS163
VSS138
AB18 VCG1063-A
VDD10_44
VSS128
AA18
VSS137
VSS115
Y18
VSS127
VSS105
W18
VSS114
VSS94
V18
VSS104
VSS85
U18
VSS93
VSS76
T18
VSS84
VSS62
R18
VSS75
AN17
SDPXWE
VSS52
P18
VSS61
AM17
SDPXCLK
C1069
N18
VSS51
AL17
SDPXDO(0)
AJ12
VSS170
AK11
DA0DQ(8)
AL10
DA0DQS(0)
AM9
DA0DQM(0)
AN8
VDD18_62
AE6
VDD18_43
AL4
VDD18_57
AM3
VDD18_59
AN5
DA0A(6)
AK4
VSS175
AL3
VSS176
AM5
VDD18_60
AJ4
DA0A(1)
AK3
DA0CKE
AN2
DA0CLK0N
AL5
DA0BA(0)
AG5
VDD18_45
AH4
DA0A(7)
AJ3
DA0A(2)
AM2
VSS181
AK5
VDD18_56
AF5
VSS152
AG4
DA0A(10)
AH3
VSS155
AL2
DA0RAS_N
AJ5
VSS167
AE5
VDD18_42
AF4
DA0A(0)
AG3
DA0A(3)
AK2
VDD18_55
AH5
VSS156
AE4
DA0DQ(19)
AF3
VSS151
AJ2
DA0CAS_N
AE3
DA0DQ(17)
AH2
DA0A(5)
AF2
DA0DQ(21)
AG2
DA0A(8)
AE2
DA0DQ(16)
*R1195
M18
VDD10_7
AK17
SDPXDO(1)
VCG1063 VDD10_8
A
C1064
0.1u
AJ17
VSS172
AN16
ADO_SDO(3)
AN14
VDD33_31
AM16
SH_GPIO0(6)
AM14
VDD18_61
AL16
SH_GPIO0(7)
AL14
VDD18_58
AK16
SDPXHS
AK14
DA0DQ(13)
AJ11
VDD18_53
AK10
DA0DQS_N(0)
AL9
VSS178
AM8
DA0DQ(1)
AN7
DA0DQ(3)
AN13
DA0DQS_N(1)
AH12
VSS160
AJ10
VSS169
AK9
DA0DQ(4)
AL8
DA0DQ(7)
AM7
DA0DQ(2)
AN6
DA0A(13)
AM13
DA0DQS(1)
AH11
DA0VREF(0)
AJ9
VDD18_52
AK8
DA0DQ(0)
AL7
VSS177
AM6
DA0A(11)
AL13
VSS180
AH10
VSS159
AJ8
VSS168
AK7
DA0DQ(5)
AL6
DA0A(4)
AK13
DA0DQM(1)
AH8
VSS158
AJ7
VDD18_51
AK6
DA0BA(2)
AJ13
VDD18_54
AJ14
VSS171
AJ16
SDPXVS
AH17
VSS162
C1070
0.1u
C1037
0.1u
C1035
0.1u
C1034
AH7
VDD18_47
AJ6
VDD18_50
VCG1063-AAH9
VDD18_48
AH6
VSS157
VCG1063-A
AH13
VDD18_49
AH14
VSS161
AH16
VDD33_25
AB17
VDD10_43
AB16
VDD10_42
C1057 C1036
VCG1063-A 0.1u
C1039
0.1u
AA17
VSS136
AA16
VSS135
AC6
VDD18_40
AN15
ADO_WS
Y17
VSS126
Y16
VSS125
C1071
C1072
1u
AB6
DA0VREF(1)
AC5
VDD18_39
AD4
DA0DQ(22)
AM15
ADO_SDO(0)
W17
VSS113
W16
VSS112
AB13
VDD10_39
AB12
VDD10_38
AA6
VDD18_38
AB5
VSS142
AC4
DA0DQM(2)
AD3
VSS146
AL15
ADO_SDO(1)
V17
VSS103
V16
VSS102
AA13
VSS132
AA12
VDD10_36
GND
AA5
VDD18_37
AB4
DA0DQ(28)
AC3
DA0DQ(20)
AD2
DA0DQ(18)
AK15
ADO_SCK
U17
VSS92
U16
VSS91
Y6
VSS121
AA4
DA0DQ(30)
AB3
VSS141
AC2
DA0DQS(2)
AD5
VSS147
AA3
DA0DQ(25)
AB2
DA0DQ(29)
AJ15
ADO_SDO(2)
T17
VSS83
T16
VSS82
W6
VDD18_35
Y5
VSS120
AA2
DA0DQ(24)
AH15
VDD33_24
R17
VSS74
C1040
VCG1063-A
C1038
P17
VSS60
AD6
VSS148
N17
VSS50
R16
VSS73
V6
VSS98
W5
VDD18_34
Y4
DA0DQ(27)
AB14 VCG1063-A
VDD10_40
P16
VSS59
U6
VDD33_18
V5
VSS97
W4
DA0DQM(3)
Y3
VSS119
AA14
VSS133
N16
VSS49
U5
UNXT
V4
SDCLK
W3
DA0DQ(31)
Y2
DA0DQS_N(3)
Y12
VDD10_34
Y13
VSS122
Y14
VSS123
M16
VDD10_5
W14
VSS110
W13
VSS109
W12
VDD10_32
U4
SDDATA(0)
V3
SDCMD
W2
VDD18_33
V12
VDD10_30
V13
VSS99
V14
VSS100
AB15
VDD10_41
U12
VDD10_24
U13
VSS88
U14
VSS89
AA15
VSS134
T13
VSS79
T14
VSS80
Y15
VSS124
R13
VSS70
R14
VSS71
W15
VSS111
P14
VSS57
V15
VSS101
N14
VSS47
P13
VSS56
T12
VDD10_18
T6
VDD33_17
T5
USTP
T4
UDIR
U3
SDDATA(1)
V2
SDCD
GND
AUDATA3
AUDSYNC
SH_TMS
ASEBRKAL_N
SH_TDI
MPMD
SH_TRST_N
M32TDI
M32TMS
V+3S
V+3PLL
V+3VS
V+1R8S
V+1R1S
V+1R1VS
V+1R1PLL
1u
U15
VSS90
M14
VDD10_3
N13
VSS46
R6
VSS69
R12
VDD10_16
P6
VSS55
R5
VSS68
P12
VDD10_14
N6
VDD33_15
P5
HDATA(8)
R4
UDIO(2)
T3
UCLK
U2
SDDATA(2)
GND
10u
C1406
GND
C1409
10u
10u
4
3
N12
VDD10_12
N5
RD_N
P4
HDATA(12)
R3
UDIO(3)
T2
UDIO(6)
AN1
VSS182
*R1402
10u
C1407
C1446
C1405
220u/4
VWV2375:NM
M13
VDD10_2
M12
VDD10_1
M6
VDD33_14
N4
HDATA(2)
P3
HDATA(15)
R2
UDIO(4)
AM1
DA0CLK1N
*C1422
1u/10
T15
VSS81
L6
VSS42
M5
VSS43
N3
HDATA(10)
P2
UDIO(0)
AL1
DA0CLK1
*C1421
220W4
R15
VSS72
8
L5
HADRS(13)
M4
HADRS(1)
N2
HDATA(13)
AK1
DA0ODT
DDR2 ch0 4memory
P15
VSS58
(25)
L4
HADRS(7)
M3
HDATA(6)
M2
HDATA(9)
AJ1
DA0CS_N
AF1
VDD18_44
AH1
DA0A(9)
0.1u
C1033
AG1
DA0A(12)
VCG1063-A
N15
VSS48
(19)
L3
HDATA(3)
C1031
AE1
DA0DQ(23)
C1444
C1030
M17
VDD10_6
C1026
C1065
M15
VCG1063-A
VDD10_4
O1(0)
L2
HDATA(5)
AD1
VDD18_41
C1404
0.1u/50
1000p/50
1000p/50
C1403
1u/10
C1433
1u/10
C1434
C1443
1u/10
C1066
1u
(1)
AC1
DA0DQS_N(2)
0
R1441
0
BDP-05FD
66
AB1
DA0DQ(26)
DAS0A5
DAS0A9
C1401
VCH1234-A
4V
220u
C1441
VCH1234-A
NM
NM
NM
C1402
*C1424
CCG1171-A
C1432
C1442
*C1423
100cp/50
C1431
VCH1269-A
1u
AA1
VDD18_36
E
C1435
GND
0
R1442
C1447
10u
Y1
DA0DQS(3)
DAS0CLK1N
W1
VDD33_19
D
10u
10u
0.1u
DA0DQ18
C1027 C1056
VCG1063-A
VCG1063-A
C1028
A 2/10
VWV2375 Only
2/2
VCG1063-A
DA0DQ22
DA0DQ19
DA0DQ17
DA0DQ16
DA0DQ23
V1
SDWP
DAS0ODT
C1029
DA0DQM2
C1032
DAS0A0
DAS0A10
DAS0A3
DAS0A8
DAS0A12
VCG1063-A
DA0DQ28
DA0DQ20
DA0DQS2
DA0DQS_N2
C1025
U1
SDDATA(3)
DAS0CKE
DAS0RAS_N
DAS0CLK1
1/2
2
1
DAS0A7
DAS0A1
DAS0A2
DAS0CAS_N
DAS0CS_N
Large size
SCH diagram
C1449
GND
A 1/10
1u
DA0DQ21
C
T1
UDIO(7)
GND
DA0DQ27
R1003 R1004
82 F 82 F
DA0DQ24
DA0DQ25
DA0DQ30
DA0DQ29
DA0DQ26
VCG1063-A
DA0DQ31
DA0DQM3
DA0DQS_N3
DA0DQS3
B
SDCLK
SDCMD
SDCD
SDWP
C1206
NM
C1207
NM
C1208
NM
R1
UDIO(5)
R1252
10k
C1024
VCG1063-A
R1212
47
R1213
47
C1205
NM
P1
UDIO(1)
10p/50
R1211
47
C1202
18p/50
C1203
18p/50
C1204
SDDATA0
SDDATA1
SDDATA2
SDDATA3
C1201
18p/50
N1
HDATA(14)
GND
A 3/10
C1408
C1448
220u/4
F
R1214
10k
SD card
M1
HDATA(11)
A
C1445
220u/4
2/2
C1023
1u
R1253
10k
SD_card
C1022
VCG1063-A
RD_N
HDATA2
HDATA10
HDATA13
HDATA14
L1
HDATA(7)
HDATA8
HDATA12
HDATA15
C1021
0.1u
HADRS1
HDATA6
HDATA9
HDATA11
(4)
HADRS13
HADRS7
HDATA3
HDATA5
HDATA7
4
3
2
1
N33
VDD18_29
P32
DA1DQS_N(3)
P33
DA1DQS(3)
R32
VDD18_32
R33
VDD33_16
T31
VDD10_23
T32
AT1CS(0)
T33
AT1CS(1)
U31
VDD10_29
U32
AT1ADR(2)
U33
AT1ADR(0)
V30
AT1IORDY
V31
AT1DMACK
V32
AT1INTRQ
V33
AT1ADR(1)
W30
AT1DATA(0)
W31
AT1DATA(15)
W32
AT1DMARQ
W33
AT1DIOW
Y30
AT1DATA(2)
Y31
AT1DATA(13)
Y32
AT1DATA(1)
Y33
AT1DATA(14)
AA29
AT1DATA(10)
AA30
AT1DATA(4)
AA31
AT1DATA(11)
AA32
AT1DATA(3)
AA33
AT1DATA(12)
AB29
VSS144
AB30
AT1DATA(8)
AB31
AT1DATA(6)
AB32
AT1DATA(9)
AB33
AT1DATA(5)
AC29
PLL0AVDD33
AC30
PLL0AVSS33
AC31
PLL0DVSS10
AC32
PLL0DVDD10
AC33
AT1DATA(7)
AD29
PLL1AVDD33
2)
AD30
PLL1AVSS33
AD31
PLL1DVSS10
AD32
PLL1DVDD10
AD33
AT1RESET
R19
VSS76
R20
VSS77
R21
VSS78
R22
VDD10_17
T18
VSS84
T19
VSS85
T20
VSS86
T21
VSS87
T22
VDD10_19
IC1001
U18
VSS93
U19
VSS94
U20
VSS95
U21
VSS96
U22
VDD10_25
V17
VSS103
V18
VSS104
V19
VSS105
V20
VSS106
V21
VSS107
V22
VDD10_31
W16
VSS112
W17
VSS113
W18
VSS114
W19
VSS115
W20
VSS116
W21
VSS117
W22
VDD10_33
R8A34019BG
U17
VSS92
V16
VSS102
AA16
VSS135
AA17
VSS136
AA18
VSS137
AA19
VSS138
AA20
VSS139
AA21
VSS140
AA22
VDD10_37
V+1R1PLL
Y22
VDD10_35
Y21
VSS130
Y20
VSS129
Y19
VSS128
Y18
VSS127
Y17
VSS126
Y16
VSS125
C1067
C1068
1u
VCG1063-A
AB22
VDD10_48
AB21
VDD10_47
AB20
VDD10_46
AB19
VDD10_45
C1069
C1070
0.1u
AB18 VCG1063-A
VDD10_44
AB17
VDD10_43
AB16
VDD10 42
AE29
VSS150
AE30
SH_TDI
AE31
VMCLK
AE32
SH_TCK
AE33
SH_TMS
AF28
VSS154
AF29
M32_TMS
AF30
M32_TDO
AF31
ATEST
AF32
SH_TDO
AF33
AMCLK2
AG28
VDD33_23
AG29
MDSEL1
AG30
M32_TRST_N
AG31
AUDATA(1)
AG32
AUDATA(0)
AG33
AMCLK1
22k
AH25
AVSSDAC33_1
AH26
AVDDDAC33_1
AH27
REXT
AH28
HDREXT
AH29
VDD33_29
AJ24
SPDIFO
AJ25
ADATAO(0)
AJ26
VDD33_30
AJ27
AVDDDAC33_2
AJ28
AVDDDAC33REF
AJ29
AVSSDAC33REF
AK23
PXDO(20)
AK24
PXVS
AK25
LRCKO
AK26
ADATAO(4)
AK27
IOBAR
AK28
DVDDDAC10
AK29
HDIOBAR
AK33
ASEBRKAK_N
AH24
VSS166
AJ23
VSS174
AK22
PXDO(15)
AJ33
AUDSYNC
AH23
VDD33_28
AJ22
PXDO(22)
AK21
PXDO(11)
AH33
AUDATA(2)
AH22
VSS165
AJ21
PXDO(16)
AK20
PXDO(6)
AK32
M32_TDI
AH21
VSS164
AJ20
VSS173
AK19
PXDO(2)
AJ32
MPMD
AH20
VDD33_27
AJ19
PXDO(10)
AK18
SDPXDO(6)
AH32
AUDATA(3)
AH19
VDD33_26
AJ18
SDPXDO(2)
AK17
SDPXDO(1)
AK31
MDSEL0
AH18
VSS163
AJ17
VSS172
AJ31
TEST(3)
AH17
VSS162
AK16
SDPXHS
AH31
AUDCK
R1146
AK30
TEST(0)
TEST0
AJ30
TEST(1)
R1145
AH30
TEST(5)
TEST1
TEST3
AL33
RESET_N
AL32
MDSEL2
AL31
TEST(2)
GND
MDSEL0
MDSEL1
MDSEL2
AL30
AVDDDAC33_5
AL29
AVDDDAC33_4
AL28
DVSSDAC10
AL27
AVDDDAC33_3
AL26
ADATAO(3)
AL25
BCKO
AL24
PXCLK
AL23
PXDO(19)
AL22
PXDO(14)
AL21
PXDO(9)
AL20
PXDO(5)
AL19
PXDO(1)
AL18
SDPXDO(5)
AL17
SDPXDO(0)
AL16
SH GPIO0(7)
AM33
M32_TCK
AM32
TEST(4)
AM31
HDPD1
AM30
AVSSDAC33_3
AM29
PD1
AM28
AVSSDAC33_2
AM27
PXFLAG
AM26
ADATAO(2)
AM25
PXWE
AM24
PXDO(23)
AM23
PXDO(18)
AM22
PXDO(13)
AM21
PXDO(8)
AM20
PXDO(4)
AM19
PXDO(0)
AM18
SDPXDO(4)
AM17
SDPXCLK
AM16
SH GPIO0(6)
V+3D
10k
AN16
ADO SDO(3)
AN17
SDPXWE
AN18
SDPXDO(3)
AN19
SDPXDO(7)
AN20
PXDO(3)
AN21
PXDO(7)
AN22
PXDO(12)
AN23
PXDO(17)
AN24
PXDO(21)
AN25
PXHS
AN26
ADATAO(1)
AN27
AVSSDAC33_4
AN28
PD0
AN29
AVSSDAC33_5
AN30
HDPD2
AN31
AVSSDAC33_6
AN32
HDPD0
AN33
AVSSDAC33_7
NM
R1153
R1156
D
R1151
R1154
R1152
R1155
NM
10k
NM
10k
C1161
VCG1063-A
GND
A_VYOUT_S_DAC
A_VCBOUT_S_DAC
A_VCROUT_S_DAC
A_VCOUT_S_DAC
10
47
R1161
22
V+3S
NM
R1197
R1201
PXHS
PXWE
PXVS
SDPXWE
SDPXHS
SDPXVS
SHGPIO7
SHGPIO6
SHGPIO5
SHGPIO4
SHGPIO3
SDPXCLK
SDPXDATA7
SDPXDATA6
SDPXDATA5
SDPXDATA4
SDPXDATA3
SDPXDATA2
SDPXDATA1
SDPXDATA0
PXDATA3
PXDATA2
PXDATA1
PXDATA0
PXDATA7
PXDATA6
PXDATA5
PXDATA4
PXDATA19
PXDATA18
PXDATA17
PXDATA16
PXDATA15
PXDATA14
PXDATA13
PXDATA12
PXDATA11
PXDATA10
PXDATA9
PXDATA8
PXDATA23
PXDATA22
PXDATA21
PXDATA20
ADATA4
PXFLAG
A_VVOUT_S_DAC
R1176
100
R1177
22
R1182
47
*R1183
R1184
47
R1185
47
R1186
47
R1187
47
R1188
47
R1189
47
*R1190
47
*R1195
*R1191
47
*R1192
47
R1193
47
100
RESET_SKY#
GND
R1171 R1172
820 F 100 F
NM
R1162
R1163
R1164
R1165
R1173
18
R1174
NM F
22
R1196
GNDV
R1199
R1198
NM
GND
ADATA3
ADATA2
ADATA1
ADATA0
LRCKO
BCKO
PXCLK
Digital Video
E
R1181
22
0
0
0
0
SPDIFO
Audio_data
JTAG
A 10/10
SPDIF_HDMI
NM
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN1301
30
V+3D
C1301
1u/10
R1338
R1339
10k
SH_TCK
M32TCK
R1322
R1321
33
33
33
33
AUDCK
M32TRST_N
M32TRST_N
10k
R1323
33
10k
R1340
R1324
33
V+3D
SH_TDI
MPMD
SH_TRST_N
SH_TMS
ASEBRKAL_N
AUDSYNC
AUDATA3
AUDATA2
AUDATA1
AUDATA0
AUDCK
RESET_N
ASEBRKAL_N
SH_TDO
SH_TDI
MPMD
SH_TRST_N
SH_TMS
SH_TCK
AUDSYNC
AUDATA3
AUDATA2
AUDATA1
AUDATA0
M32TMS
M32TDI
M32TCK
M32TDO
R1325
R1329
33
GND
F
R1326
R1301
R1302
33
R1327
33
R1328
33
GND
R1331
4.7k
R1332
4.7k
R1333
4.7k
R1334
4.7k
R1335
4.7k
8
7
GND
AE28
VSS149
V+1R1VS
AUDSYNC
MPMD
M32TDI
ASEBRKAL_N
AJ16
SDPXVS
A-VIDEO
R1144
VFUSE 10k
V+3VS
C1044
VCG1063-A
C1043
0.1u
C1042
VCG1063-A
C1041
1u
TEST5
AH16
VDD33 25
M32TCK
22k
TEST2
AMCLK1
C1040
VCG1063-A
33
M33
DA1DQ(26)
N32
DA1DQ(24)
R31
DA1DQ(31)
U30
VDD10_28
Y29
VSS131
R18
VSS75
T17
VSS83
U16
VSS91
AUDATA2
DDR2_ch1
L33
DA1DQS_N(2)
M32
DA1DQ(29)
P31
VSS67
T30
VDD10_22
W29
SH_TRST_N
4
L32
DA1DQS(2)
N31
DA1DQ(25)
R30
DA1DQM(3)
V29
AT1DIOR
8)
M31
VSS45
P30
DA1DQ(27)
U29
VDD10_27
L31
DA1DQ(20)
N30
DA1DQ(30)
T29
VDD10_21
M30
DA1DQ(28)
R29
VDD18_31
L30
DA1DQM(2)
P29
VSS66
N29
VDD18_28
AD28
VDD33_22
M29
VSS44
AC28
VSS145
L29
VDD18_26
AB28
VSS143
P21
VSS64
P22
VDD10_15
P28
VSS65
AA28
VDD33_21
N21
VSS54
P20
VSS63
R17
VSS74
T16
VSS82
A 7/10
TEST4
RESET_N
2
AUDCK
AUDATA3
67
BDP-05FD
C
A 4/10
AMCLK2
10
3
VMCLK_SKY
V+3PLL
Y28
VDD33_20
N28
VDD18_27
M21
VDD10_10
N20
VSS53
P19
VSS62
P18
VSS61
R16
VSS73
C1084
VCG1063-A
C1085
0.1u
W28
VSS118
AT1DATA7
V28
VSS108
AT1RESET
U28
VDD10_26
AT1DATA8
AT1DATA6
AT1DATA9
AT1DATA5
C1081
VCG1063-A
C1082
0.1u
C1083
1u
T28
VDD10_20
AT1DIOR
AT1IORDY
AT1DMACK
AT1INTRQ
AT1ADR1
R28
VDD18_30
AT1DATA10
AT1DATA4
AT1DATA11
AT1DATA3
AT1DATA12
C1047
1u
10
B
AT1DATA2
AT1DATA13
AT1DATA1
AT1DATA14
C1048
VCG1063-A
M28
DA1VREF(1)
M20
VDD10_9_
N19
VSS52
N22
VDD10_13
C1063
M19
VCG1063-A
VDD10_8
N18
VSS51
P17
VSS60
P16
VSS59
R1183
V+1R1S
C1061
M22
VCG1063-A
VDD10_11
M18
VDD10_7
N17
VSS50
C1062
1u
M17
VDD10_6
N16
VSS49
C1064
0.1u
M16
VDD10 5
VWV2375
22
Others
10
AT1DATA0
AT1DATA15
AT1DMARQ
AT1DIOW
C1049
0.1u
R1166
150 F
R1167
150 F
D-VIDEO
6
5
A 7/10
VWV2375
NM
NM
Others
47
47
R1192
R1195
C1050
0.1u
R1168
15
R1169
1
R1190
C1052
VCG1063-A
100
0.1u
AT1CS1
AT1CS0
AT1ADR2
AT1ADR0
C1051
VCG1063-A
R1143
C1045
DA1DQ27
DA1DQM3
DA1DQ31
VCG1063-A
M32TMS
M32TDO
R1141
1
SH_TRST_N
SH_TDI
A 3/10
DA1DQ24
DA1DQ25
DA1DQ30
DA1DQS_N3
DA1DQS3
C1054
0.1u
C1053
M32TRST_N
AUDATA1
AUDATA0
C1087
0.1u
DA1DQ28
DA1DQ29
DA1DQ26
VCG1063-A
L28
VDD18_25
C1003
R1142
SH_TDO
C1086
VCG1063-A
C1088
VCG1063-A
C1089
0.1u
A
R1001
82F
R1002
82F
C1004
1u
C1055 C1005
VCG1063-A
SH_TCK
SH_TMS
C1046
VCG1063-A
DA1DQM2
DA1DQ20
DA1DQS2
DA1DQS_N2
VCG1063-A
8
7
6
5
AUDIO
A 1/10
MAIN ASSY
A 2/10 (VXX3326
: BDP-05FD)
A
DAS0ODT
75
DA0ODT
8
3
2
1
DA0A5
DA0A9
DA0A8
DA0A12
DA0RAS_N
7
4
R2640
DAS0A12
6
DAS0RAS_N
22
DAS0A8
5
R2618
DAS0A9
75
DAS0A5
DA0A7
R2641
DA0A3
R2619
DAS0A7
DA0A0
DA0A10
DAS0A3
DAS0A10
DA0BA2
C2202
VCH1234-A
C2203
1u/10
C2205
C2204
0.1u/16
C2206
VCG1063-A
VCG1063-A
B9
DQ7
C9
VDDQ5
D9
DQ5
D8
VSSQ5
A9
VDDQ1
D7
DQ2
C8
DQ0
C7
VDDQ4
B8
VSSQ3
B7
DQS
C3
VDDQ3
A8
A7
VSSQ1
B3
DM/RDQS
C2
DQ1
DQS
A3
VSS1
B2
VSSQ2
D2
D3
DQ3
E8
CK
E9
VDD2
RAS
F7
CK
F8
F9
ODT
CAS
G7
CS
G8
E7
VSSDL
E2
VREF
E3
VSS2
F2
CKE
WE
F3
512Mbit x 8bit
IC2201
EDE5108AJBG
A2
E1
VDDL
H9
VDD3
H8
A0
G3
BA1
H2
A10
H3
A1
H7
A2
G2
BA0
G1
NC1
DA0A6
DA0A4
K9
VSS4
J2
A3
J3
A5
J7
A6
J8
A4
K2
A7
K3
A9
K7
A11
K8
A8
J1
VSS3
DA0A1
L8
A13
L7
NC3
L3
NC2
L2
A12
L1
VDD4
4
22
R2642
75
R2643
75
DA0BA1
DAS0A0
75
22
R2621
R2620
R2644
75
DA0A4
DAS0A4
R2645
75
DA0WE_N
DAS0WE_N
22
R2623
DAS0BA2
DAS0BA1
22
DA0CKE
D1
DQ4
VSSQ4
F
VCG1063-A
C1
VDDQ2
DA0A7
DA0DQ
B1
DQ6
DA0A12
22
R2622
R2647
75
A1
VDD1
C2216
1u/10
NU/RDQS
DA0A1
DA0A10
DA0A1
DA0A8
DA0A9
DA0OD
DA0RA
DA0CA
DA0CS
DA0A2
DA0A0
DA0WE_N
DA0CKE
DA0BA1
DA0BA0
DA0BA2
R2625
22
R2661
NM
0.1u/16
V+1R8ch0-1
5
C2218
22
IC2661
VCC
BDP-05FD
68
INB
R2662
NM
C2213
VCG1063-A
C2215
R2212
C2209
C2214
DA0CL
DA0CL
VCG1063-A
82 F
82 F
C2217
INA
4
GND
DA0DQ14
C2211
1u/10
DA0A5
DA0A3
DA0DQ
DA0DQ
DA0DQ
DA0DQ12
C2207
1u/10
C2212
1u/10
C2210
R2211
0.1u/16
E
OUTY
1/2
0.1u/16
0.1u/16
DA0DQ11
1
GND
B
DA0DQS
DA0DQ
DA0DQM1
DAS0CKE
R2663
C2208
VCG1063-A
DA0DQ9
2
3
NM
1/2
RESET2#_ch0
0
Large size
SCH diagram
3
2
1
GND
GND
C
A 6/10
(VXX3328 : BDP-51FD)
4
3
2
1
10.2 MAIN ASSY (2/10)
2/2
D
V+1R8ch0
V+2R5SW
IC2601
LP2996M
VREF
VSENSE
4
3
2
C2603
0.1u/16
VTT-ch0
C2604
220u/4
C2605
100u/10
R2154
0
DDR_PSW
V+2R5SW
V+3D
C2153
IC2151
S-1170B18UC-OTD
C
GND
2
VDDQ
AVIN
SD#
1
C2606
1u/10
C2607
0.1u/16
VCG1063-A
C2608
DA0CLK0
DA0CLK0N
DA0CLK1
DA0CLK1N
D2151
NM
C2152
CCG1171-A
5
PVIN
GND
GND
R2631
NM
R2632
NM
R2634
NM
R2635
NM
R2637
VIN
NC
6
7
VTT
R2611
22
R2612
22
R2613
22
R2614
22
R2615
DA0A1
DA0A2
V+1R8ch0
F2101
DTL1106-A
3
2
1
C2103
1u/10
C2102
220u/4
C2105
C2104
0.1u/16
C2106
VCG1063-A
VCG1063-A
V+1R8ch0-1
GND
C2602
DDR2 ch0
A8
A9
VDDQ1
B8
VSSQ3
B9
DQ7
A7
VSSQ1
B3
DM/RDQS
B7
DQS
DQS
A3
VSS1
B2
VSSQ2
B1
DQ6
A2
A1
VDD1
NU/RDQS
D9
DQ5
D8
VSSQ5
C9
VDDQ5
C8
DQ0
D7
DQ2
D3
DQ3
D2
D1
DQ4
VSSQ4
E9
VDD2
E8
CK
E7
VSSDL
E3
VSS2
E2
VREF
E1
VDDL
K9
VSS4
J8
A4
K8
A8
H9
VDD3
H8
A0
K7
A11
G8
J7
A6
F8
H7
A2
CS
K3
A9
G7
J3
A5
CAS
H3
A1
K2
A7
CK
G3
BA1
J2
A3
J1
VSS3
H2
A10
F7
F9
ODT
DA0A6
DA0A4
G2
BA0
RAS
F3
WE
F2
CKE
G1
NC1
IC2101
EDE5108AJBG
512Mbit x 8bit
C7
VDDQ4
C3
VDDQ3
C2
DQ1
C1
VDDQ2
DA0A1
DA0A10
8
DAS0CLK0
DAS0CLK0N
DAS0CLK1
DAS0CLK1N
DAS0A1
DA0A6
DA0BA0
0.1u/16
L8
A13
L7
NC3
L3
NC2
L2
A12
L1
VDD4
8
7
6
5
DA0A11
DA0A13
DA0CS_N
DA0ODT
DA0CAS_N
DA0RAS_N
C2116
1u/10
DA0ODT
DA0RAS_N
DA0CAS_N
DA0CS_N
DA0A2
DA0A0
DA0WE_N
DA0CKE
DA0BA1
DA0BA0
DA0BA2
DA0ODT
DA0RAS_N
DA0CAS_N
DA0CS_N
DA0A2
DA0A0
DAS0A2
75
R2638
75
R2639
75
R2640
DA0A8
DA0A12
DA0A9
DA0A12
VCG1063-A
C2115
DA0A13
DA0A13
DA0CLK0
DA0CLK0N
VCG1063-A
C2117
DA0CLK0
DA0CLK0N
22
R2616
2
0.1u/16
4
VSS
3
B
DA0A5
C2210
DAS0BA0
8
3
C2118
C2601
E
C2110
R2111
82 F
82 F
R2112
VCG1063-A
C2109
C2114
DA0A11
DA0A8
DA0A9
DA0A7
DA0A11
DA0A8
DA0DQ0
DA0DQ2
DA0DQ5
DA0DQ4
DA0DQ8
DA0DQ10
DA0DQ13
DAS0A6
22
R2617
7
4
C2113
0.1u/16
0.1u/16
DA0DQ3
0.1u/16
DAS0A11
DAS0A13
DAS0CS_N
DAS0CAS_N
DAS0ODT
DAS0A12
6
DAS0RAS_N
22
DAS0A8
5
C2208
C2111
1u/10
DA0A5
DA0A3
DA0A6
DA0A4
C2211
1u/10
1
DAS0A9
R2618
DAS0A5
DA0DQ15
VCG1063-A
C2209
C2108
VCG1063-A
DA0DQ1
VCG1063-A
DA0DQ7
DA0DQ6
C2151
CCG1171-A
100p/50
DA0DQS_N0
DA0DQS0
DA0DQM0
DA0DQS_N1
DA0DQS1
5 VOUT
1
ON/OFF
R2152
NM
R2153
NM
C2107
1u/10
C2112
1u/10
C2207
1u/10
R2633
100
R2636
100
CCG1171-A
A
220u/4
from R8A34019BG
DDR2_ch0
A 1/10
8
7
6
5
A 3/10,9/10
R2151
NM
D
F
69
BDP-05FD
C2402
220u/4
C2403
1u/10
C2405
C2404
0.1u/16
A8
A9
VDDQ1
B8
VSSQ3
B9
DQ7
A7
VSSQ1
B3
DM/RDQS
B7
DQS
DQS
A3
VSS1
B2
VSSQ2
D8
VSSQ5
F9
ODT
K9
VSS4
J8
A4
K8
A8
H9
VDD3
H8
A0
G8
K7
A11
F8
J7
A6
CS
H7
A2
G7
K3
A9
CAS
J3
A5
K2
A7
CK
H3
A1
J2
A3
F7
G3
BA1
H2
A10
RAS
G2
BA0
L8
A13
L7
NC3
L3
NC2
L2
A12
4
E9
VDD2
E8
CK
E7
VSSDL
F3
WE
F2
CKE
A 2/10
D9
DQ5
C8
DQ0
D7
DQ2
E3
VSS2
E2
VREF
DA0A1
L1
VDD4
F
DA0A
DA0A
J1
VSS3
2/2
C9
VDDQ5
C7
VDDQ4
D3
DQ3
D2
G1
NC1
IC2401
EDE5108AJBG
512Mbit x 8bit
C3
VDDQ3
C2
DQ1
E1
VDDL
DA0A1
DA0A10
C2406
A2
D1
DQ4
BDP-05FD
70
VSSQ4
C2416
1u/10
VCG1063-A
C2415
C2409
C1
VDDQ2
0.1u/16
DA0A1
DA0A
DA0A9
DA0A7
DA0OD
DA0RAS
DA0CAS
DA0CS
DA0A
DA0A
DA0WE_N
DA0CKE
DA0BA1
DA0BA0
DA0BA2
E
B1
DQ6
DA0A12
DA0CL
DA0CLK
0.1u/16
2/2
VCG1063-A
C2417
A1
VDD1
C2418
C2411
1u/10
DA0A5
DA0A3
C2410
R2411
82 F
82 F
R2412
VCG1063-A
C2414
NU/RDQS
C2413
0.1u/16
0.1u/16
DA0DQ27
DA0DQS
DA0DQ
DA0DQM3
DA0DQ
DA0DQ
DA0DQ
DA0DQ28
DA0DQ
DA0DQ30
C2407
1u/10
C2412
1u/10
VCG1063-A
VCG1063-A
Large size
SCH diagram
C2408
VCG1063-A
DA0DQ25
3
2
1
GND
1/2
4
3
2
1
A
B
C
D
5
6
7
8
A
A 3/10,9/10
V+3D
V+2R5SW
R2354
0
DDR_PSW
R2353
NM
B
R2352
NM
C2353
C2351
CCG1171-A
100p/50
R2351
NM
GND
IC2351
S-1170B18UC-OTD
5
1
ON/OFF
2
VOUT
VSS
3
4
VIN
C2352
CCG1171-A
D2351
NM
NC
C
1
V+1R8ch0-2
DDR2 ch0
A8
A9
VDDQ1
B8
VSSQ3
B9
DQ7
C2309
0.1u/16
DA0DQ16
DA0DQ18
DA0DQ21
D9
DQ5
D8
VSSQ5
C9
VDDQ5
C8
DQ0
VCG1063-A
E9
VDD2
E8
CK
DA0CLK1
DA0CLK1N
H8
A0
J7
A6
J8
A4
K7
A11
K8
A8
G8
H7
A2
K3
A9
CS
J3
A5
G7
H3
A1
CAS
G3
BA1
DA0ODT
DA0RAS_N
DA0CAS_N
DA0CS_N
DA0A2
DA0A0
F9
ODT
F8
CK
F7
RAS
F3
K2
A7
H9
VDD3
DA0A9
J2
A3
J1
VSS3
DA0A11
DA0A8
H2
A10
DA0A5
DA0A3
DA0A6
DA0A4
G2
BA0
G1
NC1
DA0A1
DA0A10
WE
F2
CKE
DA0WE_N
DA0CKE
DA0BA1
DA0BA0
DA0BA2
DA0ODT
DA0RAS_N
DA0CAS_N
DA0CS_N
DA0A2
DA0A0
DA0DQ23
VCG1063-A
C2310
E7
VSSDL
0.1u/16
D7
DQ2
E3
VSS2
E2
VREF
C2315
VCG1063-A
E1
VDDL
82 F
82 F
R2312
C2317
DA0CLK1
DA0CLK1N
C7
VDDQ4
R2311
C2410
VCG1063-A
IC2301
EDE5108AJBG
512Mbit x 8bit
D3
DQ3
0.1u/16
D2
D1
DQ4
VSSQ4
C2318
C2411
1u/10
B7
DQS
0.1u/16
DA0DQ20
DQS
DA0DQ19
DA0DQ24
DA0DQ26
DA0DQ29
DA0DQS_N2
DA0DQS2
C2308
C3
VDDQ3
0.1u/16
C2
DQ1
C2314
C2409
A7
VSSQ1
VCG1063-A
C1
VDDQ2
VCG1063-A
B3
DM/RDQS
B1
DQ6
C2313
DA0DQ17
C2408
A3
VSS1
DA0DQ22
DA0DQ31
C2307
1u/10
B2
VSSQ2
DA0DQM2
A2
A1
VDD1
NU/RDQS
C2312
1u/10
DA0DQS_N3
DA0DQS3
F2301
DTL1106-A
3
2
C2303
1u/10
C2302
VCH1234-A
C2305
C2304
0.1u/16
C2306
VCG1063-A
VCG1063-A
GND
C2407
1u/10
D
C2311
1u/10
E
DA0A6
DA0A4
DA0A11
DA0A8
DA0A7
DA0A13
L8
A13
L7
NC3
L3
NC2
L2
A12
C2316
1u/10
L1
VDD4
DA0A13
K9
VSS4
DA0A12
F
A 2/10
71
BDP-05FD
5
6
7
8
1
2
3
4
10.3 MAIN ASSY (3/10)
V+2R5SW
V+1R8ch1
IC3301
LP2996M
VDDQ
C3303
0.1u/16
VREF
5
4
AVIN
VSENSE
PVIN
SD#
VTT
GND
6
CCG1171-A
C3301
C3302
VTT-ch1
3
7
220u/4
A
MAIN ASSY
A 3/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
2
8
C3304
220u/4
1
C3305
100u/10
C3306
1u/10
C3307
0.1u/16
C3308
VCG1063-A
R3342
DA1BA2
GND
DA1A4
DA1A12
DA1A13
A 1/10
75
SD_card
R3343
DA1ODT
DA1WE_N
from R8A34019BG
DA1RAS_N
V+2R5SW
SDDATA3
SDCMD
SDCLK
(guard L/S=200)
SDDATA0
SDDATA1
SDDATA2
SDCD
SDWP
75
R3344
DA1BA0
C3151
CCG1171-A
DA1CS_N
V+3D
DDR_PSW
C3715
NM
R3706
47
R3705
47
DA1A6
DA1A2
DA1A1
V+3D
R3701
47
R3702
47
R3703
47
R3704
47
R3710
10k
C3710
1000p
R3711
10k
C3711
1000p
NM
R3707
22
R3708
22
C3716
DA1A5
75
2
DA1A8
DA1A9
DA1A11
1
GND
F3701
DTL1106-A
3
C3702
220u/4
C3701
1u/10
C3704
NM
C3703
1000p
DA1A7
V+3SD
DDR2_ch1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A 1/10
JA3701
DKP3748-A
SD card connector
R3301
4.7
DAS1CLK0
R3331
NM
R3333
NM
R3334
NM
R3335
82
220
R3709
75
DAS1CLK0N
DA1CLK0
DA1CLK0N
R3332
NM
R3302
4.7
R3341
R3303
DAS1A3
DA1A3
DAS1A10
DA1A10
DAS1A0
DA1A0
75
22
R3304
DAS1BA2
DA1BA2
DAS1A4
DA1A4
DAS1A13
DA1A13
DAS1A11
D
DA1A11
22
R3305
DAS1CS_N
DA1CS_N
DAS1CAS_N
DA1CAS_N
DAS1ODT
DA1ODT
DAS1RAS_N
DA1RAS_N
22
SD card
R3306
DAS1A6
DA1A6
from R8A34019BG
DAS1BA0
E
DA1BA0
DAS1BA1
DA1BA1
DAS1WE_N
DA1WE_N
22
R3307
DAS1A1
DA1A1
DAS1A2
DA1A2
DAS1A7
DA1A7
22
V+3SD
R3791
10k
R3792
10k
R3308
DAS1A12
DA1A12
DAS1A8
DA1A8
DAS1A9
DA1A9
DAS1A5
DA1A5
22
SDCMD
SDDATA3
SDDATA0
SDDATA1
SDDATA2
R3347
75
R3311
22
DAS1CKE
DA1CKE
V+1R8ch1-1
A 5/10
IC3361
RESET2#_ch1
1
5
VCC
R3361
NM
INA
0
R3363
INB
2
3
4
GND
OUTY
R3362
NM
GND
NM
F
A 3/10
72
BDP-05FD
1
2
3
4
A 2/10,9/10
R3152
NM
R3153
NM
GND
75
R3345
R3346
C
R3154
0
C3153
C3713
NM
C3714
NM
C3717
NM
C3712
10p/50
DA1BA1
DA1CAS_N
100p/50
B
5
6
7
8
A
DDR2 ch1
A2
A4
4
VIN
DA1A13
DA1A6
DA1A4
DA1A11
DA1A8
DA1ODT
DA1RAS_N
DA1CAS_N
DA1CS_N
DA1A2
DA1A0
DA1CLK0
DA1CLK0N
DA1DQ7
DA1DQ5
DA1DQ0
C3113
C3114
1u/10
VCG1063-A
0.1u/16
C3112
C3111
DA1DQ4
DA1DQ15
DA1DQ8
DA1DQ10
VCG1063-A
2
C3152
CCG1171-A
NC
VSS
3
1
R3152
NM
VOUT
5
A2
A 2/10,9/10
C3153
A5
A6
100p/50
DDR_PSW
R3153
NM
R3154
0
ON/OFF
2
V+3D
A1
R3151
NM
C3151
CCG1171-A
_N
_N
V+1R8ch1-1
1
3
B
VCG1063-A
V+1R8ch1
D3151
NM
A0
F3101
DTL1106-A
VCG1063-A
IC3151
S-1170B18UC-OTD
C3110
V+2R5SW
C3107
1u/10
_N
0.1u/16
C3108
E_N
C3109
ODT
DA1DQ13
DA1DQS_N1
DA1DQS1
13
DA1DQS_N0
DA1DQS0
12
C3102
CCH1688-A
C3103
1u/10
B9
DQ15
C9
VDDQ5
D9
DQ13
E9
VDDQ6
F9
DQ7
G9
VDDQ10
A8
B8
C8
DQ8
D8
VSSQ5
E8
F8
VSSQ8
G8
DQ0
C7
VDDQ4
D7
DQ10
F7
LDQS
G7
VDDQ9
UDQS
C3104
0.1u/16
GND
A9
VDDQ1
B7
UDQS
A7
VSSQ1
C3105
LDQS
VSSQ3
E7
VSSQ6
H9
DQ5
J9
VDD3
K9
ODT
J8
CK
K8
L8
CK
CS
H8
VSSQ10
H7
DQ2
J7
VSSDL
M9
VDD4
P9
VSS5
M8
A0
N8
A4
P8
A8
R8
NC6
M7
A2
N7
A6
P7
A11
R7
NC5
L3
BA1
M3
A1
N3
A5
P3
A9
R3
NC4
L2
BA0
M2
A10
N2
A3
P2
A7
R2
A12
K7
L7
RAS
CAS
VCG1063-A
A1
C3106
IC3101
EDE5116AJBG
512Mbit X 16bit
VCG1063-A
A7
A8
A9
11
A3
VSS1
B3
UDM
C3
VDDQ3
D3
DQ11
E3
VSS2
F3
LDM
G3
VDDQ8
H3
DQ3
J3
VSS3
K3
A2
NC1
B2
VSSQ2
C2
DQ9
D2
VSSQ4
E2
NC2
F2
VSSQ7
G2
DQ1
H2
VSSQ9
J2
VREF
K2
CKE
A1
VDD1
B1
DQ14
C1
VDDQ2
D1
DQ12
E1
VDD2
F1
DQ6
G1
VDDQ7
H1
DQ4
J1
VDDL
WE
L1
NC3
N1
VSS4
C
R1
VDD5
K0
C3122
1u/10
C3121
DA1A12
DA1A7
DA1A9
DA1A5
DA1A3
DA1A10
82 F
82 F
C3123
R3112
0.1u/16
GND
DA1WE_N
DA1CKE
DA1BA1
DA1BA0
DA1BA2
DA1A1
R3111
0.1u/16
C3124
0.1u/16
VCG1063-A
C3120
DA1DQ2
DA1DQ3
DA1DQ1
C3119
DA1DQ6
DA1DQM0
DA1DQ14
DA1DQ12
DA1DQ9
VCG1063-A
VCG1063-A
C3118
0.1u/16
DA1DQ11
DA1DQM1
A0
C3117
C3116
A3
10
VCG1063-A
C3115
1u/10
0N
A2
A4
13
11
D
DA1A13
DA1A6
DA1A4
DA1A11
DA1A8
DA1ODT
DA1RAS_N
DA1CAS_N
DA1CS_N
DA1A2
DA1A0
DA1CLK0
DA1CLK0N
DA1DQ23
DA1DQ16
DA1DQ21
C3214
1u/10
C3213
VCG1063-A
VCG1063-A
0.1u/16
VCG1063-A
C3212
C3211
DA1DQ18
DA1DQ26
DA1DQ29
DA1DQ28
VCG1063-A
C3210
V+1R8ch1-2
1
3
C3207
1u/10
F3201
DTL1106-A
A1
0.1u/16
A6
A0
C3209
C3208
DA1DQ24
DA1DQS_N3
DA1DQS3
_N
DA1DQS_N2
DA1DQS2
_N
_N
ODT
E_N
2
A9
VDDQ1
B9
DQ15
C9
VDDQ5
D9
DQ13
B8
C8
DQ8
D8
VSSQ5
C7
VDDQ4
D7
DQ10
E9
VDDQ6
F9
DQ7
G9
VDDQ10
E8
F8
VSSQ8
G8
DQ0
F7
LDQS
G7
VDDQ9
H9
DQ5
J9
VDD3
K9
ODT
J8
CK
K8
CK
CS
J7
VSSDL
K7
L7
RAS
CAS
M9
VDD4
P9
VSS5
C3202
CCH1688-A
A1
A2
C3203
1u/10
A7
C3204
0.1u/16
A8
UDQS
C3205
H8
VSSQ10
LDQS
VSSQ3
B7
UDQS
A7
VSSQ1
E7
VSSQ6
H7
DQ2
L8
M8
A0
N8
A4
P8
A8
R8
NC6
M7
A2
N7
A6
P7
A11
R7
NC5
L3
BA1
M3
A1
N3
A5
P3
A9
R3
NC4
L2
BA0
M2
A10
N2
A3
P2
A7
R2
A12
E
VCG1063-A
C3206
IC3201
EDE5116AJBG
512Mbit X 16bit
C3
VDDQ3
D3
DQ11
E3
VSS2
F3
LDM
G3
VDDQ8
H3
DQ3
J3
VSS3
K3
A2
NC1
B2
VSSQ2
C2
DQ9
D2
VSSQ4
E2
NC2
F2
VSSQ7
G2
DQ1
H2
VSSQ9
J2
VREF
K2
CKE
A1
VDD1
B1
DQ14
C1
VDDQ2
D1
DQ12
E1
VDD2
F1
DQ6
G1
VDDQ7
H1
DQ4
J1
VDDL
L1
NC3
N1
VSS4
R1
VDD5
C3222
1u/10
VCG1063-A
C3221
WE
DA1A12
DA1WE_N
DA1CKE
DA1BA1
DA1BA0
DA1BA2
DA1A1
82 F
82 F
F
GND
0.1u/16
R3212
R3211
C3223
0.1u/16
C3224
DA1DQ19
0.1u/16
C3220
VCG1063-A
DA1DQ22
DA1DQ17
DA1DQ20
DA1DQM2
DA1DQ30
DA1DQ25
C3219
0.1u/16
C3217
VCG1063-A
DA1DQ27
C3216
DA1DQ31
DA1DQM3
VCG1063-A
B3
UDM
C3218
A3
VSS1
C3215
1u/10
KE
DA1A7
A5
DA1A9
A9
DA1A10
A8
DA1A5
DA1A3
VCG1063-A
12
A 3/10
73
BDP-05FD
5
6
7
8
1
2
3
4
10.4 MAIN ASSY (4/10)
A
MAIN ASSY
A 4/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
B
Clock Generator
R3866
CLOCK_SEL
NM
V+3CG
C3862
10u
C3861
1u/10
C3863
1
16
VDD1
NM
NC
2
15
VSS1
C
A 1/10
VMCLK_PLUM
NM
VDD3
VSS2
VSS3
C3865
NM
11
XTI
AO1
XTO
SO1
8
NM
R3868
27MHz
C3871
NM
12
VDD2
6
7
NM
C3870
NM
SO2
5
X3861
C3866
NM
13
MO2
C3864
C3869
NM
for SKY
33.87MHz
FSEL
4
NM
C3868
NM
AMCLK2
NM
14
MO1
NM
R3862
R3863
SO3
3
R3861
VMCLK_SKY
A 1/10
IC3861
NM
10
R3864
9
NM
R3865
AMCLK1
for SKY
36.86MHz
NM
C3867
NM
R3867
NM
A 1/10
GND
1
3
C3804
10u
F3801
DTL1106-A
C3802
VCH1234-A
C3803
1u/10
V+3D
R3833
V+3CG
0
C3801
NM
R3811
ETH_CLK
for RTL8201
25.00MHz
NM
IC3801
PDJ015A
2
IC3831
NM
A 6/10
5
1
VCC
INB
R3805
R3801
D
R3806
R3802
S0/A0/CLK_SEL
Y5
S1/A1
Y4
18
3
C3805
X3801
1000p
VSS1226-A
NM
R3822
27MHz
VCC_OUT2
GND1
GND4
17
4
R3821
0
1000p
22
R3804
SCON_SCL0
14
VCC2
VCC_OUT1
GND2
GND3
8
13
SDATA
Y1
SCLOCK
Y0
10
L3802
C3807
1000p
12
R3818
11
NM
R3819
R3832
OUTY
AMCLK_33/36M
NM
C3832
NM
AMCLK1
for SKY
36.86MHz
AMCLK2
22
C3817
NM
4
C3812
NM
for SKY
33.87MHz
C3816
NM
R3843
A 1/10
100
IC3841
NM
5
INB
for PLUM
27.00MHz
VCC
A
C3841
NM
2
VMCLK_SKY
for SKY
27.00MHz
22
RE
1
VMCLK_PLUM
C3824
18p/50
GND
3
GND
C3814
NM
C3819
NM
GND
R3815
33
CTF1384-A
R3817
15
7
22
C3823
18p/50
Y2
9
R3803
SCON_SDA0
Y3
CLK_IN1
INA
CTF1384-A
L3814
1000p
16
CLK_IN0
6
C3806
C3808
C3831
NM
2
R3813
NM
A 1/10
INA
3
4
GND
R3842
OUTY
AMCLK_fs32k
NM
C3818
NM
C3842
NM
C3809
NM
C3810
NM
C3822
12p/50
A 1/10,5/10
VCC1
5
C3821
13p/50
CTF1384-A
19
2
10k
NM
L3801
20
1
10k
NM
GND
E
F
A 4/10
74
BDP-05FD
1
2
3
4
A 10/10
5
6
7
8
A
Nor FLASH
V+3D
F3501
DTL1106-A
1
C3503
VCG1063-A
C3502
B
V+3FM
CCG1171-A
2
220u/4
C3501
3
GND
SH_BUS
A 1/10
HADRS0
IC3501
S29GL512P11TFI020
HADRS24
R3501
1
0
2
HADRS23
HADRS16
3
HADRS15
4
HADRS14
5
HADRS13
6
HADRS12
7
HADRS11
8
A23
A24
A22
NC4
HADRS9
10
HADRS20
11
HADRS21
12
A16
A14
BYTE#
A13
VSS2
A12
DQ15/A-1
A11
DQ7
A10
DQ14
A9
DQ6
A8
DQ13
A19
DQ5
A20
DQ12
WE#
16
RB_N
17
HADRS19
18
HADRS18
19
HADRS8
20
HADRS7
21
HADRS6
22
HADRS5
23
HADRS4
24
HADRS3
25
HADRS2
26
51
HDATA15
50
HDATA7
49
HDATA14
48
HDATA6
47
HDATA13
46
HDATA5
45
HDATA12
44
HDATA4
43
C3504
42
1u/10
DQ11
WP#/ACC
HDATA6
HDATA13
41
HDATA3
40
HDATA10
39
HDATA2
38
HDATA9
37
HDATA1
36
HDATA8
35
HDATA0
DQ2
DQ9
A7
DQ1
A6
DQ8
DQ0
A5
34
A4
OE#
A3
VSS1
HDATA12
C
HDATA4
HDATA11
HDATA3
HDATA10
HDATA2
HDATA9
HDATA1
R3594
10k
HDATA8
HDATA0
RD_N
33
32
A2
HDATA5
R3592
10k
R3593
10k
DQ10
A17
HDATA7
HDATA14
HDATA11
DQ3
A18
R3596
10k
HCS_N3
R3597
10k
HCS_N6
CE#
31
A1
HADRS1
A0
27
R3502
0
HDATA15
VCC
A21
RY/BY#
WE_N0
V+3FM
HADRS17
R3591
10k
DQ4
RESET#
WP_N
HADRS26
0
52
14
15
HADRS25
0
R3510
53
13
HADRS22
R3509
55
54
A15
9
HADRS10
56
30
NC1
NC3
NC2
VIO
28
C3505
29
0.1u/50
WE_N1
R3506
D
R3503
NM
100k
R3511
M
RESET2#
R3504
100k
NM
R3512
0
GND
C3506
1000p/50
V+3FM
R3508
4.7k
GND
RESET2#_ETHER
NOR_CS
A 5/10
A 10/10
0
R3513
A 6/10
GND
R3553
NM
R3551
4.7k
R3552
4.7k
V+3FM
E
1
HCS_N1
2
R3555
5
INB
VCC
C3507
INA
0
0
HCS_N0
R3505
IC3551
TC7SH08FUS1
R3554
0
3
4
GND
1u
OUTY
GND
F
A 4/10
75
BDP-05FD
5
6
7
8
1
76
2
F
100k
R4208
3
C4223
0.1u/16
RESET
A 8/10
A 5/10
BDP-05FD
4
VOUT
2
IC4201
BU4809F
10k
R4241
3
0.1u/16
GND
GND
VOUT
BD45282G
SUB
4
SCON_RQI
GND
0
3
22
R4022
NC
47k
1
VWV2376
IC4002
NM
R4020
2
100p/50
100k
C4018
V+1R1D
NM
5
1
1
57
VDD
R4069
VDD
2
2
3
3
VDD2
PWM2
PWM3
VSS1216-A
P12/SCK0
P13/SO1
P14/SI1/SB1
P15/SCK1
P16/T1PWML
P17/T1PWMH/BUZ
R4026
NM
X4001
GND
VDD1
4
4.7k
ER
470
VOUT
Others
1
P81/AN1_O.D
GND
R4017
R4072
CF1
2
49
IC4202
NM
50
R4024
3
PB2
1
0.1u
V+1R8S
C4021
VDD
60
4
52
NM
R4023
P80/AN0_O.D
NC
51
C4071
1u/10
P73/INT3/T0IN
VOUT
29
22
30
SCON_XRESET
54
SCON_IR
XT2/AN11
2
58
VDD
CF2
3
59
NC
R4021
10k
P72/INT2/T0IN 51.
P71/INT1/T0HCP/AN9 50.
P70/INT0/T0LCP/AN8_O.D 49.
R4059
27
10k
R4045
4.7k
21
62
61
V+3D
R4019
P27/INT5/T1IN
GND
63.
62.
P83/AN3_O.D
IC4001
PDC178A8
48
P10/SO0
P82/AN2_O.D
47
PB5
P84/AN4_O.D
P85/AN5_O.D
64.
R4016
10k
*R4017
4.7k
C4015
NM
46
45
P11/SI0/SB0
R4015
10k
NM
P22/INT4/T1IN
1
2
3
4
5
6
7
8
9
10
SW_1R8LH
64
IC4203
NM
C4222
C4014
C4013
P86/AN6_O.D
P21/URX/INT4/T1IN
F_KEY2
0
R4014
44
31
F_KEY1
1000p
PC0
P24/INT5/T1IN
0
43
23
R4013
1000p
C4004
1000p
P23/INT4/T1IN
F_KEY0
C4012
22
Q4003
DTC124EUA
R4224
P_ON
PC1
PC2
PB6
42
28
NM
R4221
47k
100
R4048
PC3
PC4
PB7
41
40
39
P07/T7O
FL_OFF
F_LED4
22k
Q4002
DTC124EUA
NM
P06/T6O
R4222
100
.17
.18
D4002
1SS355
100
NM
220
100
100
R4044
100
22
22
22
100
100
100
100
R4043
R4042
R4041
R4040
R4039
R4038
R4049
R4036
R4037
VCG1063-A
C4022
NM
100
FIP_DAT
FIP_STB
FIP_SCK
F_LEDPWM2
F_LEDPWM3
SCON_RQO
FAN-PWM
FAN-PWM_Hi
NM
R4073
A 1/10
RESET_SKY#
HDMI/DVI#
SCON_SDA0
SCON_SCL0
A 1/10,4/10
A 3/10
A 4/10
RESET2#_ch1
RESET2#
A 10/10
RESET3#
A 1/10
3
GND
R4223
10k
100k
R4210
R4047
1000p
C4003
R4046
11
R4034
R4033
R4032
R4031
C4024
NM
F_LED5
P26/INT5/T1IN
F_LED6/DOOR_OPEN
26
NM
25
V+3E
P25/INT5/T1IN
VSS2
12
13
14
15
B
100p/50
100k
R4209
Q4004
24
PC5/DBGP0
P20/UTX/INT4/T1IN
38
P00
P01
P02
16
C4027
2SA1576A(QR)
VCH1269-A
C4002
*R4069
20
DBGP0
PC6/DBGP1
19
R4225
DBGP1
PB3
PC7/DBGP2
32
37
.32
DBGP2
PB4
P03
2
C4221
POWER_ON
V+3E
P04
R4063
22k
from HDMI
(VXX3328 : BDP-51FD)
1SS355
NM
C4001
V+6E
R4058
Q4001
2SA1576A(QR)
22
36
R4057
0.1u
R4055
VDD3
R4068
35
R4052
C4011
17
VSS3
C4026
PB0
R4056
18
P05/CKO
VCG1063-A
34
33
22
22
RS232C_PON
22
R4062
NM
R4061
0
from HDMI
MAIN ASSY
A 5/10 (VXX3326
: BDP-05FD)
D4001
GND
PB1
R4053
R4054
GND
22
22
DBGP2
22
R4206
100
22
9
R4051
DBGP2
R4067
22
DBGP1
22
DBGP0
SCON_XYCBCRMUTE
R4066
R4204
100
NJM2566_S1
R4065
22
R4205
100
SCON_XSVMUTE
22
7
NJM2566_S2
R4064
8
V+3SE
I/XP
22
DBGP1
3
HD/SD#
2
RESOLUTION
1
HDMI_CEC
SCON_XRESET
F4001
VTL1171-A
SUB-CON
DBGP0
R4203
100
R4202
100
V+3E
HDMI_HPD
SCON_RXD
SCON_RXD
6
A 1/10
R4207
100k
IC4101
S-1170B33UC-OTS
SCON_TXD
SCART/PIN
5
4
RXD_PCON
R4201
100
to VIDEO
SCON_TXD
GND
3
TXD_PCON
0.1u
C4201
VideoAMP
A 7/10
BLANK
XDBG_RST
2
NM
1
CN4201
GND
SCON_RXD
VIN
D4101
NM
SCON_TXD
C4102
CCG1171-A
5
VOUT
C
V+3E
GND
NC
VSS
3
V+6E
100
D
V+3E
1
E
ON/OFF
2
R4101
A
4
2.2u/10
C4101
1
4
10.5 MAIN ASSY (5/10)
C4025
NM
NM
63
VSS1
56
XT1/AN10
55
53
VCG1063-A
RES#
C4020
C4019
0.01u
C4017
0.01u
A 1/10
VCG1061-A
C4016
NM
R4018
R4071
22k
NM
0.1u/16
C4203
C4202
5
B
6
28
29
30
IR
LED_HD/DOOR_OPEN
19
LED_HDMI
27
18
GND
V+5E
17
V+3E
LED_FLOFF
16
GND
26
15
GND
25
14
GND
GND
13
V+12SW
GND
12
GND
24
11
V+3D
LED_PON
10
GND
23
9
FLDATA
GND
8
GND
22
7
FLCLK
21
6
GND
GND
5
FLSTB
20
4
GND
GND
3
7
L4407
CTF1306-A
L4417
C4418
NM
F_IR
4
GND
INA
INB
TC7SH08FUS1
OUTY
IC4351
3
2
1
GND
V+5E
2
VSS1216-A
X4001
R4353
220
D4351
RB501V-40
GND
3
3
L4414
R4403
220
R4351
C4351
680p/50
Others
CTF1306
NM
BDP-05FD
8
GND
GND
2
3
1
RKN1004-A
JA4351
7
GND
R4402
NM
100
R4352
VCC
R4355
R4401
NM
SCON_IR
GND
5
10k
F_LED6/DOOR_OPEN
F_IR
F_LED5
F_LEDPWM2
C4352
0.1u/50
V+3E
2
0.1u/50
C4355
C4419
NM
CTF1394-A
L4416
C4413
1000p/50
V+5E
F_LED4
F_LEDPWM3
V+3E
V+12SW
FIP_DAT
FIP_SCK
1
1
NM
C4357
CTF1306-A
CTF1306-A
L4421
F_KEY1
4
5
R4071
22k
C4412
0.1u/50
L4415
CTF1306-A
*L4414
CTF1306-A
L4413
CTF1306-A
L4412
CTF1394-A
L4411
CTF1394-A
L4408
CTF1394-A
VOUT
F_KEY0
FIP_STB
GND
VDD
220k
GNDF
L4406
CTF1306-A
V+3D
CTF1306-A
CTF1306-A
L4405
CTF1306-A
L4403
CTF1306-A
L4402
IC4002
BD45282G
SUB
ER
A 1/10
C4423
NM
C4422
NM
C4420
NM
C4421
NM
C4411
0.1u/50
C4410
1000p/50
C4409
0.1u/50
C4414
1u/16
C4408
100u/16
C4407
0.1u/50
C4406
1000p/50
C4404
22p/50
C4405
22p/50
C4417
NM
L4404
3
2
1
R4354
NM
R4404
*R4403
NM
C4403
22p/50
C4416
1000p/50
C4402
1000p/50
C4401
0.1u/50
GND
100k
R4072
6
LED_BLUE
2
VKN1620-A
KEY1
CN4401
KEY0
GND
V-23SW
L4410
1
47u/35
C4415
GND
1
C4202
CTF1394-A
V-23SW
2
VOUT
0.1u/16
C4203
GND
IC4201
BU4809F
NM
4
3
VDD
V+1R1D
1
VOUT
2
SCON_RQI
GND
IC4202
NM
V+1R8S
VDD
22
R4022
NC
4
GND
3
4
NC
5
8
A
SR IN
B
100p/50
C4356
C
NM
C4358
D
E
LED_PON
VWV2376
NM
0
CN1
F
A 5/10
77
1
2
3
4
10.6 MAIN ASSY (6/10)
A
MAIN ASSY
A 6/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
Ether
ETHER
A 1/10
ETX_CLK
R4581
ERX_CLK
R4582
100k
100k
B
ERXD0
ERXD1
ERXD2
R4583
10k
ERXD3
R4584
ERX_DV
V+3D
10k
CN4601
NM
GND
1
2
V+3D
3
R4602
ETXD7
ETX_ER
0
A 4/10
6
RESET2#_ch0
A 2/10
NM
R4603
ECOL
7
ETX_EN
R4588
22
ETXD6
8
A 10/10
FS32K
ETXD3
9
ETXD2
R4585
10k
10
ETXD1
ERXD5
11
ETXD0
ERXD4
12
ERXD7
ERXD6
13
V+3D
14
ETX_CLK
15
ETH_CLK
A 4/10
R4589
10k
16
for RTL8201
25.00MHz R4601
17
ERXD7
NM
ERX_CLK
R4587
NM
18
D
R4586
10k
R4596
10k
4
5
RESET2#_ETHER
C
C4601
1u/10
19
20
ERXD3
GND
21
ERXD2
22
ERXD1
V+3D
23
ERXD0
R4591
10k
24
ERX_DV
ETXD0
25
ECRS
ETXD1
26
ERX_ER
ETXD2
27
EMDC
ETXD3
28
EMDIO
29
ECOL
E
R4592
10k
30
R4593
10k
GND
EMDC
ECRS
ERX_ER
ETX_EN
EMDIO
R4594
10k
R4595
10k
F
A 6/10
78
BDP-05FD
1
2
3
4
5
6
7
8
A
HDMI
V +3 H
V +1 R8 H
12,28,32
V +5 S W
14,44
38,42,55
B
45
53,66,89
64,79,99
H D MI O U T
J A 5001
HDMI
Connector
AKP7220-A
C
10/10
2K
V +5 S W
IC5001
V +1 R8 H
IC5301
S-1170B18UC-OTD
5
4
H D M I Tr a n s m i t t e r
VIN
VOUT
1
ON/OFF
D
V +3 H
V +5 S W
IC5311
S-L2980A33MC-C6S
5
1
VIN
VOUT
+3D
3
ON/OFF
V +6 E
..................................................................
V +5 H D
IC5321
NJM2370U1-05
5
VIN
Digital Video and Audio Bus from IC1001
1
E
4
VOUT
CONT
F
A 6/10
79
BDP-05FD
5
6
7
8
1
2
3
4
10.7 MAIN ASSY (7/10)
A
MAIN ASSY
A 7/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
Large size
SCH diagram
1/2
from R8A34019BG Video Out
B
GND
*
3
*C
33
Others
Only
*C6502
F
BDP-05FD
1
2
3
*R65
*Q6501
2SA1576A
(QR)
6
*C650
VCG1057-A
E
80
*R6521
0
VCG
A_VCROUT_S
C2
100 F
R6503
NM
B1
*R6501
V+3D
680
V+5V
B
E1
GND
*R6508
*Q6502
2SA1576A
(QR)
A_VCBOUT_S
C2
R6507
NM
B1
V+3D
E1
A_VCROUT_S_DAC
Others
Only
E2
B_PXVS
R6502
NM
C
E
ADV_SCL1
A_VCBOUT_S_DAC
*C6503
V+5V
680
A_VYOUT_S
B2
*R6522
0
VCG1057-A
A_VVOUT_S
A_VCOUT_S
C1
*R6505
100 F
R6506
NM
*R6512
*Q6503
2SA1576A
(QR)
VCG1057-A
E2
GND
V+3D
*R6523
0
R6511
NM
*C6504
VCG1057-A
UMF21N-TLB
C1
B2
Others
Only
680
V+5V
*Q6504
2SA1576A
(QR)
*C6505
GND
V+3D
R6515
NM
680
*R6509
100 F
R6510
NM
*R6516
V+5V
*R6520
*Q6505
2SA1576A
(QR)
D
*R6524
0
R6514
NM
R6519
NM
R6518
NM
*R6513
100 F
GND
*R6525
0
V+3D
*R6517
100 F
Others
Only
Others
Only
GND
1/2
VWV2375 Only
ADV_SDA1
B_PXHS
A_VYOUT_S_DAC
A_VVOUT_S_DAC
A_VCOUT_S_DAC
2/2
C
A 1/10
A 1/10
4
PXDATA2
PXDATA3
PXDATA4
PXDATA5
PXDATA6
PXDATA7
PXDATA8
PXDATA9
PXDATA11
PXDATA10
PXDATA14
PXDATA15
PXDATA16
*R6303
22
22
22
22
*R6304
22
*R6301
*R6305
22
22
*R6306
*R6302
*R6307
*C6313
VCG1063-A
V+3DAD
L6301
V+3AAD
0.1u/50
*C6322
GND
*C6311
CCG1171-A
*C6312
0.1u/16
*C6309
0.1u/16
*C6307
CCH1688-A
*C6308
CCG1171-A
V+1R8DPD
V+1R8VD
20
V+3AAD
A_VCOUT_DAC
V+
1
A_VYOUT_Y/C_DAC
2
V-
GND
A_VCROUT_DAC
A_VCBOUT_DAC
A_VYOUT_DAC
*R6331
A_VVOUT_DAC
*IC6302
NM
3
TRIM/NC
8
7
V+3VA
*C6318
0.15u/10
*R6325
GND
A_VCROUT_S
81
BDP-05FD
V+1R8VD
48
46
47
45
150
V+5V
NM
V+3VD
VREF
COMP1
VCG1063-A
*C6321
VCG1057-A
*C6327
CTF1394-A
VCG1063-A
C6320
NM
*C6319
0.012u/50
*C6317
*R6324
*C6316
0.15u/10
R6503
NM
NM
*R6332
V+1R8DAD
SFL/MISO
RSET1
44
43
42
41
40
39
38
37
36
35
34
33
*L6303
NM
*C6303
0.1u/16
48.
47.
DAC1
DAC2
DAC3
VAA
AGND
DAC4
DAC5
DAC6
RSET2
PVDD
COMP2
EXT_LF1
*C6315
20
*R6323
0.012u/50
150
*R6322
*R6336
V+3D
*C6324
0
SDPXVS
0
*C6302
CCG1171-A
1. VDD_IO
2. Y0
3.9k
0
*R6337
S_VSYNC
*C6304
220u/4
*C6305
CCG1171-A
*C6306
0.1u/16
Y1
Y2
Y3
Y4
Y5
Y6
Y7
VDD_1
DGND_1
Y8
Y9
C0
C1
C2
SDPXDATA7
3.9k
NM
NM
*R6339
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
NM
10k
R6309
*R6308
*L6302
CTF1394-A
GND
R6319
R6320
*R6347
50
SDPXHS
0
Others
Only
2200p/50
F
3.9k
6
5
1k F
20
*R6327
*R6326
*R6329
*R6328
VCG1057-A
220
*C6501
*L6304
CTF1394-A
*R6504
CTF1394-A
*C6314
D
*C6323
2200p/50
680
*Q6501
2SA1576A
(QR)
S0
*R6340
30
22
*R6317
0
*C6326
R6502
NM
*R6348
GND
A_VCROUT_S_DAC
100 F
(except VWV2375)
S1
C9
PXDATA23
*R6338
*R6521
0
*R6501
0
29
S_HSYNC
SDPXDATA0
*R6341
PXDATA22
49
32
SDPXDATA1
0
52
S2
30.
31.
32.
*R6321
31
0
*R6342
CLKIN_A
EXT_LF2
PGND
51
0
*R6343
53
VIDEO DAC
54
C8
SDPXDATA2
55
28
VDD_2
C5
22
S4
27
57
C
SDPXDATA3
S5
P_VSYNC
S3
C7
26
PXDATA21
56
25
0
PXDATA19
C6
PXDATA20
SDPXCLK
0
*R6344
*C6325
0.1u/16
DGND_2
*IC6301
ADV7340BSTZ
P_BALNK
*R6316
58
B_PXVS
24
*R6318
SDPXDATA4
S6
P_HSYNC
23
*R6315
0
B_PXHS
22
59
21
0
60
22
*R6314
ADV_SCL1
10
68
*R6346
SDPXDATA6
S8
SDA/SCLK
SDPXDATA5
S7
SCL/MOSI
0
*R6345
61
*R6312
20
ADV_SDA1
22
*R6313
62
S9
64
18
ALSB/SPI_SS
19
GND_IO
63
CLKIN_B
17
22
C4
22
*R6311
C3
*R6310
PXDATA17
PXCLK_ADV7340
*C6328
33p/50
PXDATA18
*C6329
33p/50
Digital Video
A 1/10
8
7
6
5
from R8A34019BG
A
B
VCG1063-A
E
F
GND
*C6151
*C6141
VCG1057-A
VCG1057-A
VCG1057-A
V+5V
*C6161
*R6015
*R6020
*R6021
*R6016
0
NM
0
NM
NM
C6012
CCG1171-A
C6013
CCG1171-A
C6014
C6015
CCG1171-A
NM
0
R6005
NM
R6006
C6004
CCG1205-A
R6007
3.3k
R6008
8
9
10
11
12
13
14
15
16
SYIN
GND1
SYOUT
V+4
GND4
V+3
YOUT
CBSW
YIN
LPFSW
PROUT
GND3
NC3
PBOUT
V+2
NC2
GND2
PS2
PBIN
PRIN
25
24
23
22
21
20
19
18
17
CCG1205-A
C6006
C6008
NM
CCG1205-A
NM
C6009
C6010
NM
R6010
0
A_VYOUT_Y/C
A_VYOUT
A_VCBOUT
A_VCROUT
D6206
NM
D6207
NM
D6208
NM
D6209
NM
D6210
NM
D6211
NM
D6212
NM
C6203
1000u/6.3
7
C6204
1000u/6.3
8
C6205
1000u/6.3
9
C6206
1000u/6.3
68 (F)
75 (F)
R6204
68 (F)
*R6205
*R6206
68 (F)
4.7
0
R6214
5.6
*R6215
*R6216
5.6
NM
C6214
NM
C6215
NM
NM
C6216
GND
C6401
NM
C6402
NM
C6403
NM
3
2
1
4
1
8
9
8
7
6
5
4
3
2
1
GND
CTRL3
CTRL2
CTRL1
Pr_GND
Pr
Pb_GND
Pb
Y_GND
Y
GND
*
VKB1198-A
A_VVOUT_S
A_VYOUT_S
A_VCBOUT_S *R6022
*R6017
0
CCG1171-A
NM
GND
*R6401
NM (F)
*R6402
NM (F)
*R6403
NM
10
NM
11
4
R6009
NM
V+5V
V+5V
NM
NM (F)
*R6404
NM
*R6405
*R6406
GND
A 7/10
6.8k
YCBCRMUTE
*Q6401
NM
*Q6403
GND
NM
*R6018
NM
HD/SD#
NM
V+5V
F
0
A_VCROUT_S *R6023
VWV2375
0
NM
NM
0
NM
0.1u/16
R6143
NM
V+5V
V+5V
I/XP
*Q6402
NM
*Q6404
NM
E
R6153
NM
R6163
NM
5 B2
6 C1
GND
*Q6405
4 E2
*CN6401
GND
GND
E1 1
NM
*R6409
*R6412
NM
BDP-05FD
82
B1 2
C2 3
GND
2/2
NM
C6405
3
2
1
*R6413
C6404
C6406
*R6407
*R6408
F
NM
F
NM
NM
F
NM
F
NM
*R6410
*R6411
GND
VWV2316 Only
2/2
*Q6404
NM
1/2
NJM2566_S1
NJM2566_S2
C
NM
NM
D
C6005
Large size
SCH diagram
A 5/10
VideoAMP
*R6144
*R6154
*R6164
Others
NM
0
0
NM
CCG1171
NM
R6003
R6004
R6013
R6018
R6023
R6019
C6016
C6018
680
*Q6141
2SA1576A(QR)
680
*Q6151
2SA1576A(QR)
680
*Q6161
2SA1576A(QR)
R6142
NM
R6152
NM
R6162
NM
*R6141
300 F
*R6151
300 F
*R6161
300 F
A
4
3
2
1
B
VWV2375:NM
SCON_XYCBCRMUTE
A 1/10
0
*R6003
NM
R6006
0
R6005
NM
NM
*C6018
*R6004
C6003
CCG1205-A
C6017
CCG1171-A
C6002
VCG1063-A
R6001
3.3k
C6001
CCH1688-A
XYCBCRMUTE
C6004
CCG1205-A
D6002
RB501V-40
R6002
6.8k
D6003
RB501V-40
V+5V
A 1/10
11
10
9
8
7
6
5
4
3
2
1
R6011
0
R6012
0
30
NJM2566_S1
NJM2566_S2
C6010
NM
C6009
CCG1205-A
C6006
C6008
NM
CCG1205-A
C6007
A_VVOUT
A_VCOUT
R6024
NM
19
20
21
22
23
24
25
26
27
28
29
31
32
D6004
RB501V-40
S1
SDCOUT
S2
V+1
GND3
NC3
PBOUT
V+3
YOUT
GND4
SYOUT
V+4
VOUT
NC4
SCOUT
GND2
NC2
V+2
YIN
CBSW
SYIN
GND1
VIN
MIXSW
NC1
SCIN
PS1
IC6001
NJM2566AV
V+5VAMP
XSVMUTE
PBIN
V+3VD
4
*R6208
NM
A_VCBOUT
A_VYOUT
A_VYOUT_Y/C
RESOLUTION
D6201
NM
D6202
NM
D6203
D6204
D6205
NM
NM
D6208
NM
D6209
NM
D6206
NM
D6207
NM
NM
VideoAMP
1000u/6.3
C6205
8
1000u/6.3
C6204
7
C6203
1000u/6.3
5
0.1u/50
C6202
6
C6201
1000u/6.3
GND
*Q6002
NM
BLANK
D6210
A 5/10
*R6207
NM
(F)
R6201
75
*R6202
68 (F)
*R6203
68 (F)
75 (F)
R6204
68 (F)
*R6205
R6211
0
*R6212
4.7
*R6213
4.7
0
R6214
5.6
*R6215
NM
C6214
NM
C6213
NM
C6212
NM
C6211
E
C6215
3
2
7
5
6
2
4
3
1
8
VWV2315/VWV2316
VWV2375/VWV2376
JA6001
AKB7159
AKB7146
JA6002
VKB1198
VKB1165
D
SCART/PIN
from SCON
HD/SD#
V+5V
D6001
RB501V-40
C6011
CCG1171-A
*C6016
CCG1171-A
C6012
CCG1171-A
C6013
CCG1171-A
12
13
14
VIDEO AMP
SCON_XSVMUTE
VCG1057-A
VCG1057-A
R6113
NM
NM
0
NM
0
YCBCRMUTE
*R6019
0
NM
*R6013
*R6014
0
*R6015
*R6020
*R6021
*R6016
NM
C6014
L6001
V+5V
A_VCOUT_S
A_VVOUT_S
A_VYOUT_S
A_VCBOUT_S *R6022
*R6017
C
CTF1394-A
R6123
NM
V+5V
VCG1057-A
GND
GND
R6133
NM
V+5V
VCG1057-A
*R6114
*R6124
*C6111
*C6121
680
*Q6111
2SA1576A(QR)
680
*C6131
*Q6121
2SA1576A(QR)
*C6141
8
7
6
5
A
GND
R6132
NM
R6143
NM
*R6134
*R6144
*JA6001
*JA6002 AKB7159-A
198-A
680
*Q6131
2SA1576A(QR)
680
41
A(QR)
R6112
NM
R6122
NM
*R6111
75 F
*R6121
75 F
*R6131
75 F
8
7
6
5
B
VWV2316 Only
F
A 7/10
83
BDP-05FD
1
2
3
4
10.8 MAIN ASSY (8/10)
A
MAIN ASSY
A 8/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
from SYPS
R7603
0
B
V+12ASW
Q7601
NM
R7601
0
CN201
G
D
SW-12A
13
GNDA
12
SW+12A
11
GNDA
10
GND
9
GND
8
7
SW+1.5V
6
GND
5
GND
4
SW+2.5V
3
SW+2.5V
2
GND
1
C7604
NM
C7605
NM
C7654
NM
C7655
NM
NM
NM
C7607
0.1u
NM
NM
C7657
C7656
R7652
NM
C7651
SW+1.5V
C7606
C7603
0.1u
CN7001
AKM1284-A
C
GNDA
C7653
C7652
47u/16
C7602
47u/16
R7602
NM
V+12A
R7651
0
0.1u
V-12ASW
Q7651
V-12A
NM
R7653
C7601
0.1u
0
R7001
NM
C7001
V+1R5SW
0.1u/50
C7009
NM
C7002
V+2R5SW
0.1u/50
CN7002
AKM1282-A
G
CN202
E
GND
11
SW+5V
10
SW+5V
9
GND
8
EV+6V
7
P-ON
6
V+5SW
C7003
0.1u/50
C7008
100u/10
C7004
0.1u
C7005
1000p
GND
5
SW+12V
4
C7006
V+6E
R7501
47
POWER_ON
A 5/10
V+12SW
0.1u
GND
3
SW-23V
2
GND
1
C7007
V-23SW
0.1u
F
GND
A 8/10
84
BDP-05FD
1
2
3
4
5
6
7
8
A
Regulator
B
V+6E
NC
NM
C7424
CCG1171-A
C7423
4
for VIDEO AMP
VIN
VOUT
VSS
3
1
ON/OFF
2
100p/50
100
C7425
R7423
NM
R7421
V+5SW
V+5V
C7422
2.2u/10
C7421
100u/10
5
D7421
NM
C
IC7421
S-1170B50UC-OUJ
GND
NM
D7501
V+6E
D
IC7501
S-L2980A50MC-C7J
1
5
V+5E
VOUT
for IR
VSS
3
4
ON/OFF
NC
C7503
100u/16
2
C7502
CCG1171-A
2.2u/10
C7501
VIN
E
GND
F
A 8/10
85
BDP-05FD
5
6
7
8
1
2
3
4
10.9 MAIN ASSY (9/10)
R7101
3.3k
A
V+5SW
R7102
10k
V+1R5SW
Regulator
C7107
EN
7
YB
C7105
1u YB
6
IN
GND
C7106
CCH1688-A
C7104
5
10u
4
V+1R1D
3
1
C7101
1000p
B
10u
R7104
2
SS
for MAIN LSI
C7103
VCH1234-A
R7103
1.2k D
C7102
FB
D
OUT
2.7k
IC7101
TPS74901KTW
BIAS
1u
R7105
330 D
GND
V+2R5SW
IC7201
S-1170B18UC-OTD
C
for MAIN LSI
220u 4V
C7204
VCH1269-A
NC
VSS
3
1
1u
ON/OFF
2
10k
C7205
R7206
C7203
CCG1171-A
VIN
4
VOUT
V+1R8D
R7201
NM
C7201
100u/10
C7202
CCG1171-A
5
D7201
NM
GND
R7205
R7204
6.8k
DDR_PSW
0
A 2/10,3/10
D
V+5SW
IC7301
S-1170B33UC-OTS
for MAIN LSI
for Others
V+3VA
for VIDEO of MAIN LSI
C7304
220u/4
C7303
CCG1171-A
NC
VSS
3
V+3D
VIN
4
5
1
100p/50
C7305
R7303
NM
E
ON/OFF
2
R7302
NM
R7301
100
C7302
CCG1171-A
C7301
100u/10
V+1R8D
VOUT
D7301
NM
GND
V+5SW
IC7311
S-1170B33UC-OTS
or
C7313
CCH1688-A
NC
C7312
CCG1171-A
VIN
5
4
VSS
3
ON/OFF
2
1
A 9/10
100p/50
C7314
R7313
NM
F
R7311
100
C7311
CCG1171-A
R7312
NM
VOUT
D7311
NM
for VIDEO DAC Analog
GND
86
BDP-05FD
1
2
3
4
5
6
7
8
A
MAIN ASSY
A 9/10 (VXX3326
: BDP-05FD)
(VXX3328 : BDP-51FD)
C1
B2
UMF21N-TLB
C1
B2
E2
E2
C
B
B
E
E1
B1
C2
E1
B1
C2
V+3D
R7321
V+3VD
for VIDEO DAC Digital I/O
VWV2375:NM
C
C7323
NM
*C7322
CCG1171-A
0
GND
D
V+5SW
*IC7331
S-1170B18UC-OTD
for VIDEO DAC Core
*C7333
VCH1234-A
NC
*C7332
CCG1171-A
4
VIN
VOUT
VSS
3
1
*C7334
1u/16
*R7333
33k
ON/OFF
2
*R7332
22k
V+1R8VD
R7331
NM
*C7331
CCG1171-A
5
D7331
NM
GND
E
SI
g
F
A 9/10
87
BDP-05FD
5
6
7
8
A 1/10
2/2
C
(VXX3328 : BDP-51FD)
1/2
Audio_data
XMMUTE
ADAC_CS2
ADAC_MDO
ADAC_MDC
ADAC_CS1
A 1/10
XAMUTE
from R8A34019BG
10k
R8925
V+3D
R8926
10k
R8901
47
R8902
47
R8903
47
R8924
47
L8901
ADATA1
BCKO
LRCKO
R8908
R8907
R8906
R8905
CTF1384-A
ADATA3
V+3D
C8901
0.1u/50
C8902
NM
C8932
VCG1063-A
C8922
VCG1063-A
C8923
VCG1063-A
0
C8903
0.1u/50
C8904
NM
C8933
VCG1063-A
0
C8931
100p/50
0
C8930
100p/50
0
C8929
100p/50
0
C8928
100p/50
0
C8927
10p/50
0
C8926
100p/50
C8924
VCG1063-A
C8925
NM
C8905
0.1u/50
R8911
R8909
V+12A
V-12A
ADATA2
D
R8910
100u/10
ADATA0
V+5E
R8921
C8906
100p/50
C8907
0.1u/50
C8908
100p/50
R8922
R8923
NM
NM
GND
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
CN8901
1
V+3D
DAC_ML
GND
DAC_MC
DAC_ML2
DAC_MDO
AMCLK
GND
LRCK
GND
BCLK
GND
ADATA1
GND
ADATA3
GND
ADATA2
GND
ADATA0
V+5E
XAMUTE
GNDA
V+12A
V+12A
GNDA
V-12A
V-12A
BDP-05FD
88
1/2
4
3
2
1
0
GND
C8921
Audio_control
from R8A34019BG
AUDIO I/F
GNDA
VKN1617-A
E
MAIN ASSY
A 10/10 (VXX3326
: BDP-05FD)
Large size
SCH diagram
4
3
2
1
10.10 MAIN ASSY (10/10)
A
B
D 1/2 CN1
F
2
3
V+3SPDIF
C8006
1u
C8005
1
2
R8007
NM
FBIN
IC8001
ICS571MLF
ICLK
VDD2
8
7
5
6
R8002
33
R8004
22
R8005
22
1
2
3
IC8011
TC7WH74FU
CK
D
Q
GND
1u
C8012
C8011
VCG1063-A
PR
Vcc
CLR
Q
1Y
1B
1A
3A
4Y
4B
4A
XST
8
6
7
5
16
15
14
13
12
11
10
9
R8015
1k
R8039
10k
C8033
NM
R8038
10k
R8037
10k
R8014
NM
D
R8040
10k
SPDIF_ON
R8041
NM
R8042
NM
NM
R8043
R8044
NM
R8045
NM
SPDIFO
0
R8051
8
7
F8001
VTL1171-A
1
GND
R8001
47
GND2
CLK
GND1
VDD1
CLK/2
4
GND
IC8031
TC74VHC157FTS1
1
2A
3B
VCC
2B
3Y
SELECT
2Y
0.1u
V+3D
33/36MHz
3
R8031
2
3
4
5
6
GND
1000p
C8032
B
4
FS32K
22
R8035
22
7
8
AUDIO Digital
C8031
C8001
NM
AMCLK_FF
VCG1063-A
R8006
22
C8002
VCH1234-A
C8003
1000p
C8007
NM
R8003
NM
AMCLK_fs32k
33/24MHz
R8036
22
R8032
NM
R8033
10k
6
5
A 6/10
C
R8049
NM
GND
R8048
22
A 1/10
R8046
NM
R8047
NM
GND
A 4/10
8
7
6
5
A
C8004
1000p
A 1/10
E
F
89
BDP-05FD
1
2
3
4
A
B
R8805
NM
R8803
NM
TH8801
NM
R8804
NM
R8806
NM
6
5
2
3
NM
7
NM
R8801
R8807
NM
IC8801
NM
1
IC8801
8
4
GND
NM
R8802
NM
R8808
C
A 5/10
FAN-PWM_Hi
FAN-PWM
FAN
Large size
SCH diagram
V+12SW
R8822
NM
R8821
0
1/2
2
C8711
NM
R8811
0
Q8812
R8812
NM
NM
Q8811
4
R8711
NM
5
6
1
3
R8712
NM
GND
Q8701
NM
2
D
5
6
UMD2N
4
1
Q8702
NM
3
C8712
NM
R8815
560
R8713
NM
C8713
NM
R8813
470
R8814
NM
Q8801
2SC5712
GND
2/2
D8801
UDZS7R5(B)
C8805
0.1u/50
C8801
47u/16
C8804
NM
0
C8802
47u/16
L8801
0.1u/50
R8816
E
C8806
NM
C8803
0.1u
2
1
CN8801
AKM1273-A
2/2
TO FAN
F
A 10/10
90
BDP-05FD
1
2
3
4
5
6
7
8
A
R8206
B
47
*R8121
0
GND
GND
D
R8203
NM
0
*R8108
*C8102
*R8105
1.5k
C8201
NM
GND
VCH1267-A
R8205
NM
Q8201
NM
*C8117
8
1
*R8106
D
Polaris
10
75 D
RN1/10SC75R0D-T
LMH6658MMX
7
4 *IC8101
8
LMH6658MMX
4 *IC8101
VCG1063-A
R8202
NM
R8204
NM
2
3
6
5
*R8132
0
*C8104
0.1u/50
R8201
NM
680
*R8103
22p/50
*R8107
*R8104
330
RN1/16SE6800D-T
*R8102
0
*R8131
VCH1267-A
*R8101
*C8174
0
*C8184
100
*C8173
0.1u/50
D
*C8175
1000p/50
*C8183
0.1u/50
C
C8103
NM
*C8185
1000p/50
2.2k
*C8172
0.1u/50
*R8171
1.2k
*C8101
*C8182
0.1u/50
82p/50
*R8172
2.2k
NM
*Q8171
2SC4081(QR)
*Q8181
2SA1576A(QR)
*R8182
1.2k
R8122
NM
RN1/16SE2201D-T
*R8181
3.3k
V+12ASW
V-12ASW
*C8171
0.1u/50
*C8181
0.1u/50
R8123
C8116
NM
*C8111
*R8111
10k
VCH1241
0
*R8112
VWV2376:NM
11
C8114
NM
V+3SPDIF
0.1u/50
C8115
GND
1
3
2
5
4
VKX1023-A
*JA8001
2
1
*CN8101
E
NM
JA8001
VWV2315/VWV2316
VWV2375
VWV2376
VKX1023
VKX1024
VKS1002
F
A 10/10
91
BDP-05FD
5
6
7
8
1
2
3
4
10.11 FLKY ASSY (BDP-05FD)
A
R1
R17
C14
R36
R15
10u/50
Q1
FLDC-(-22v)
NM
NM
R43
NM
C20
C18
C19
22u/25
2SA2060
D2
UDZS3R3(B)
0.1u/50
C13
12k
12k
R71
R8
C7
Q2
100u/16
V-23V
FLDC+(-18v)
B
560
R85
NM
R87
NM
R44
NM
R79
NM
R88
NM
R59
NM
R80
560
560
R83
560
R86
NM
R81
560
R76
560
R77
560
R84
NM
R48
NM
R49
NM
R52
NM
R46
NM
R47
560
R74
NM
R40
NM
R41
560
R75
NM
R38
NM
R39
NM
R53
NM
R32
NM
R33
NM
R27
NM
R28
560
NM
R82
R25
GND
10u/50
C16
R24
8.2k
R72
8.2k
R21
TP3
GND
NM
C4
NM
NM
NM
NM
R9
0
2SA2060
10u/50
0
R2
C3
C6
NM
R12
0
IC1
RPM7140-H4
Vout
1
GND
2
Vcc
3
TP1
0.1u/50
L1
C2
1u/16
TP2
NM
R11
GND
V5EV
R10
D1
UDZS2R0(B)
C8
0.1u/50
C5
NM
C1
NM
100
GND
R50
47
47
1u/16
150k
C31
R73
CTF1394-A
R57
R54
R51
JV1
NM
C
GND
R37
0
47
SW3R3
TP7
TP6
STOP
TP4
10u/6.3
R6
GND
4
KEY1
5
GND
3
IR
2
LED_HD
1
C50
VKN1290-A
0
TP8
GND
0.1u/50
CN1
Q3
DTC124EUA
C17
GND
GND
1000p/50
Q4
DT
C23
1000p/50
R3
0
2.06
2.15
2.23
-
SCAN FWD
1.48
1.57
1.67
SCAN REV
0.91
0.99
1.08
RESOLUTION
0.53
0.59
0.65
OPEN/CLOSE
0
0
0
-
F
PLAY
-
JP1
JP2
1
1
1
JP4
JP5
1
1
GND GND GND GND GND
39k
PLAY
VSG1024-A
GND
TP10
1
V+12
2
KEY0
3
GND
4
LED_PON
5
GND
CN991
PAUSE
2.2k
C
-
NM
JP3
0.1u/50
2.65
CN3
TP12
2.59
C21
2.53
0.1u/50
STOP
R30
1
P_ON
R23
S5
max
2
typ
0.1u/50
min
C15
KEY1
TP11
TP9
KEY0
C24
Signal Level
V+12
10k
Function
V3EV
GND
R22
GND
VKN1236-A
GND
GND
GND
B
92
BDP-05FD
1
2
3
4
TP13
2.2k
4
V5EV
LED_
V+12
SLR-343VC(NPQ)
LED_FL OFF
LED_HD(RED)
GND
NM
5
C22
6
R35
7
GND
GND VKN1236-A
V+12
2.2k
8
GND
GND
D3
C59
GND
LED_PON
GND
C32
KEY_SENSE
3
100p/50
9
2.2k
10
1u/16
11
GND
C10
GND
LED_BLUE
0.1u/25
V3EV
CTF1394-A
12
C12
*C69
10u/6.3
*C70
CTF1394-A
0.01u/50
C55
0.1u/50
1u/16
*C68
13
14
0.1u/50
*C67
GND
LED_HDMI
GND
R107
*R18
C9
0.1u/50
15
0.1u/50
16
100u/16
C11
17
GND
V3EV
FLKY ASSY : KEY0
S1: OPEN
S2: Resolution
S3: SKIP Rev
S4: SKIP Fwd
S6: PAUSE
S7: STOP
0.1u/50
GND
GND
C30
1
2
0.1u/25
C52
1u/16
C26
C28
1
*S7
2
*S6
2
NM
PAUSE
NM
1
1
*S4
2
NM
SKIP Fwd
SKIP Rev
OPEN
10k
R7
*CN2
V3EV
TP5
D4
18
*S3
GND
NM
GND
R42
V+12
1
2
GND
NM
19
NM
C56
20
GND
C47
NM
21
C57
GND
SW3R3
C58
22
1
1
GND
SLR-343VC(NPQ)
R31
E
FLDATA
*C66
A 5/10 CN4401
D
GND
GND
V3EV
24
23
NM
GND
25
FLCLK
GND
NM
*S2
26
*R34
NM
NM
27
*R29
NM
2
28
FLSTB
*R26
NM
Resolution
KEY1
GND(FLDC+)
GND
NM
*R20
NM
*S1
29
*R16
2
30
KEY0
*R19
*R14
NM
V-23V
KEY0
0.1u/50
C51
100u/16
GND
GN
GND
A
1000p/50
C23
GND
Q4
DTC124EUA
5
GND
*Q5
DTC124EUA
TP14
*C29
0.1u/50
GND
NM
GND
*Q6
DTC124EUA
6
GND
*Q7
DTC124EUA
TP23
GND
7
GND
SG[13]
CF1/XT1
S30
52
SG[12]
CF2/XT2
S29
51
SG[11]
50
SG[10]
49
SG[9]
S27
*R65
TP24
*Q8
DTC124EUA
1
GND
KEY_SENSE(WHITE)
V+12
GND
1000p/50
TP25
BDP-05FD
8
NM
S38
GR[1-12],SG[1-36]
61
SG[21]
SG[22]
SG[23]
62
SG[24]
64
S39
SG[25]
65
63
SG[26]
66
SG[27]
SG[28]
SG[29]
67
68
VDD3
S40
S41
S42
S43
S44
S45
69
70
S47
SG[30]
SG[31]
71
S46
SG[32]
72
SG[33]
74
73
SG[34]
75
S48
SG[35]
76
SG[36]
S49
S50
S51
S52
S53
77
78
560
R93
560
R95
560
R92
560
R94
560
NM
R100
2.2k
NM
R106
NM
C49
NM
SG[1]
SG[2]
SG[3]
SG[4]
SG[5]
SG[6]
SG[7]
SG[8]
SG[9]
SG[10]
SG[11]
SG[12]
SG[13]
SG[14]
SG[15]
SG[16]
SG[17]
SG[18]
SG[19]
SG[20]
SG[21]
SG[22]
SG[23]
SG[24]
SG[25]
SG[26]
SG[27]
SG[28]
SG[29]
SG[30]
SG[31]
SG[32]
SG[33]
SG[34]
SG[35]
SG[36]
GR[1]
GR[2]
GR[3]
GR[4]
GR[5]
GR[6]
GR[7]
GR[8]
GR[9]
GR[10]
GR[11]
GR[12]
C48
NM
NM
NM
R13
1
F-
P1
P2
P3
P4
P5
P6
P7
P8
P9
P10
P11
P12
P13
P14
P15
P16
P17
P18
P19
P20
P21
P22
P23
P24
P25
P26
P27
P28
P29
P30
P31
P32
P33
P34
P35
P36
1G
2G
3G
4G
5G
6G
7G
8G
9G
10G
11G
12G
F+
NM
R99
NM
R105
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
NM
R98
NM
R104
NM
R5
2.2k
R97
NM
R103
54
560
R91
560
R90
C34
1000p/50
7
C46
S17
S16
VDD2
53
R68
BLUE
40
39
38
S31
2.2k
S15/T15
36
VP1
S14/T14
35
37
S13/T13
S12/T12
S11/T11
S10/T10
S9/T9
34
33
GR[12] 32
GR[11] 31
S8/T8
S7/T7
S6/T6
VSS1
100p/50
SG[1]
29
SG[14]
8
2.2k
SG[2]
41
28
GR[10] 30
54
D9
S18
GR[9]
S32
C65
42
P71_INT1/T0HCP
GR[8]
RES#
SG[17]
1000p/50
S19
S5/T5
7
SG[18]
57
C53
SG[3]
P70/INT0/T0LCP/RMIN
S4/T4
SG[15]
150k
SG[19]
58
SLR-343VC(NPQ)
R67
C54
SG[4]
43
27
55
SG[20]
59
0.1u/50
44
S20
GR[7]
S33
S28
*C44
S21
18
P07/AN7
TP17
GR[6]
P17/INT3/T0IN
60
0.1u/50
V+12
1.5k
SG[5]
17
P06/AN6
TP16
S3/T3
6
S26
NM
*C64
45
26
S37
100p/50
S22
25
SG[16]
R57
P01/AN1
*R66
TP15
P05/AN5
GR[5]
P12/SO0
P10/SO0
P11/SI0/SB0
S36
*C43
SG[6]
16
S2/T2
56
PDC182A
1.5k
46
S1/T1
S34
IC2
*D8
S23
24
560
R89
NM
R82
2.2k
R96
R4
NM
R81
NM
R80
2.2k
R102
R101
NM
R79
NM
R59
FLDC+(-18v)
SLR343WBCT(MNPQ)
*R64
P04/AN4
23
79
80
10u/50
C37
0.1u/50
C35
1000p/50
C33
NM
R44
NM
R88
-22v)
0.1u/50
V+12
*C41
*R60
100p/50
SG[7]
15
GR[4]
GND
1.5k
GND
NM
*C63
SG[8]
47
NM
GR[3]
P00/AN0
P16/INT2/T0IN
VDD1
*R63
V+12
P14/SI1/SB1
1.5k
48
S24
S0/T0
P13/SO1
*D7
*C40
NM
S25
P03/AN3
22
2
SLR343BC4T(JKLM)
*R62
BLUE
*C38
20
P02/AN2
14
21
12
5
10
GR[2]
11
S35
9
GR[1]
1
0.1u/50
19
13
R69
NM
3
100p/50
SW3R3
10k
*R61
10k
*R58
R70
0
GND
NM
*C62
*D6
*C36
*D10
X1
SLR343WBCT(MNPQ)
100p/50
1.5k
V+12
*R56
LED_FLoff(RED)
NM
*C61
*D5
*C27
R78
4
P15//SCK1
1u/16
NM
R87
560
R86
6
NM
GND
1.5k
NM
C31
560
R83
560
R85
560
R84
B
C42
TP13
C32
0.1u/25
C30
1u/16
C28
C26
100u/16
GND
NM
GND
SLR343BC4T(JKLM)
*R55
2
NM
HD(RED)
CN1
GND
F
5
C25
4
KEY1
NM
GND
100p/50
KEY_SENSE
3
R45
V3EV
2.2k
TP6
1
2
D4
C60
TP7
V3EV
R42
0
*R18
3V
*C39
NM
C22
2.2k
P5
SLR-343VC(NPQ)
100p/50
5
8
A
FLKY ASSY
(VWG2612 : BDP-05FD)
V1
VAW1094-A
GND
GND
GND
B
GND
SW3R3
VNF1142-A
2
C
GND
SW3R3
*CN2
D
GND
GND VKN1236-A
WHITE
0
0
LED_HDMI(RED)
V+12
E
GND
C45
GND
Q9
DTC124EUA
GND
F
B
93
1
2
3
4
10.12 FLKY ASSY (BDP-51FD)
A
R1
R15
R17
R36
10u/50
C14
0.1u/50
FLDC-(-22v)
NM
Q2
NM
R43
NM
C20
C18
C19
22u/25
2SA2060
D2
UDZS3R3(B)
V-23V
FLDC+(-18v)
B
NM
R79
560
NM
R44
NM
R80
NM
R81
NM
R87
NM
R59
560
560
R85
560
R86
NM
R88
NM
R82
560
R76
560
R83
560
R77
560
R84
NM
R48
NM
R49
NM
R52
NM
R46
NM
R47
560
R74
NM
R40
NM
R41
560
R75
NM
R38
NM
R39
NM
R53
NM
R32
NM
R33
NM
R27
NM
R24
R25
GND
R28
C16
10u/50
8.2k
R21
R72
8.2k
TP3
GND
NM
C4
NM
NM
NM
NM
12k
12k
R71
Vcc
3
100u/16
C3
C6
0.1u/50
Q1
C13
GND
R8
Vout
1
0
2SA2060
C7
TP1
R12
0
IC1
RPM7140-H4
10u/50
0
R2
L1
NM
TP2
2
C2
NM
R11
GND
V5EV
1u/16
R10
D1
R9
UDZS2R0(B)
C8
0.1u/50
C5
NM
C1
NM
100
GND
R50
47
47
1u/16
150k
C31
R73
CTF1394-A
R57
R54
R51
JV1
NM
C
GND
R37
0
47
SW3R3
15
GND
R107
C55
13
CTF1394-A
R6
NM
14
GND
LED_HDMI
0.1u/50
TP7
TP6
V3EV
2
KEY_SENSE
3
GND
4
KEY1
5
GND
GND
NM
CTF1394-A
12
11
1u/16
LED_HD(RED)
CN1
GND
1000p/50
0
2.06
2.15
2.23
-
SCAN FWD
1.48
1.57
1.67
SCAN REV
0.91
0.99
1.08
RESOLUTION
0.53
0.59
0.65
OPEN/CLOSE
0
0
0
PLAY
-
JP1
JP2
1
1
1
JP4
JP5
1
1
39k
PLAY
VSG1024-A
GND GND GND GND GND
GND
TP10
1
V+12
2
KEY0
3
GND
4
LED_PON
5
GND
CN991
PAUSE
2.2k
C
-
NM
JP3
TP11
2.65
CN3
TP12
2.59
C21
2.53
0.1u/50
STOP
R30
S5
P_ON
R23
1
max
2
typ
0.1u/50
min
C15
TP9
KEY1
C24
Signal Level
Function
KEY0
0.1u/50
V+12
10k
V3EV
GND
R22
GND
VKN1236-A
GND
GND
GND
B
94
BDP-05FD
1
2
3
4
2.2k
Q4
DT
C23
1000p/50
R3
R42
TP13
Q3
DTC124EUA
C17
GND
NM
GND
0.1u/50
D4
TP8
SLR-343VC(NPQ)
C50
C22
1
VKN1290-A
R35
2
D3
C59
3
LED_HD
100p/50
4
IR
2.2k
GND
5
V5EV
LED_
V+12
6
LED_FL OFF
E
0.1u/50
7
C12
8
2.2k
GND
V+12
SLR-343VC(NPQ)
R31
GND
GND
9
100u/16
C11
GND
LED_PON
GND
10
C10
GND
F
C32
1
GND
LED_BLUE
-
0.1u/25
C30
*CN2
NM
*R18
0.1u/50
C9
0.1u/50
16
1u/16
C26
1
*S7
2
STOP
VSG1024-A
1
*S6
2
PAUSE
VSG1024-A
1
*S4
2
*S3
SKIP Fwd
VSG1024-A
1
Resolution
VSG1024-A
OPEN
V3EV
TP5
FLKY ASSY : KEY0
S1: OPEN
S2: Resolution
S3: SKIP Rev
S4: SKIP Fwd
S6: PAUSE
S7: STOP
17
NM
*C70
V3EV
C52
*C69
GND
18
NM
GND
GND
0.1u/25
NM
*C68
GND
GND
TP4
19
NM
*C67
V+12
GND
10k
20
R7
GND
C47
GND
GND
NM
21
NM
C56
SW3R3
NM
22
C57
GND
C58
23
*C66
A 5/10 CN4401
D
FLDATA
V3EV
GND
VSG1024-A
24
GND
2
GND
10k
SKIP Rev
25
10k
*S2
26
FLCLK
*R34
10k
VSG1024-A
27
FLSTB
*R29
10k
GND
2
28
*R26
2.2k
2
KEY1
GND(FLDC+)
10k
*R20
2.2k
1
29
*R16
*S1
30
KEY0
*R19
*R14
1
0.1u/50
C51
V-23V
KEY0
C28
100u/16
GND
GN
GND
A
1000p/50
C23
GND
Q4
DTC124EUA
5
SLR343BC4T(JKLM)
*Q5
NM
*Q6
DTC124EUA
GND
GND
6
GND
*Q7
NM
NM
TP23
GND
7
GND
S17
S16
VDD2
53
SG[13]
CF1/XT1
S30
52
SG[12]
CF2/XT2
S29
51
SG[11]
50
SG[10]
49
SG[9]
S27
0
V+12
*R65
TP24
*Q8
NM
1
GND
*CN2
KEY_SENSE(WHITE)
V+12
GND
1000p/50
TP25
BDP-05FD
8
NM
BLUE
40
39
38
SG[33]
SG[32]
74
73
72
71
S50
S49
S48
S38
GR[1-12],SG[1-36]
61
62
SG[21]
SG[22]
SG[23]
S39
SG[24]
63
VDD3
SG[25]
64
SG[26]
66
S40
SG[27]
67
SG[28]
SG[29]
68
69
SG[30]
65
S41
S42
S43
S44
S45
S46
S47
S51
S52
SG[31]
SG[34]
75
70
SG[35]
76
S53
C49
NM
SG[1]
SG[2]
SG[3]
SG[4]
SG[5]
SG[6]
SG[7]
SG[8]
SG[9]
SG[10]
SG[11]
SG[12]
SG[13]
SG[14]
SG[15]
SG[16]
SG[17]
SG[18]
SG[19]
SG[20]
SG[21]
SG[22]
SG[23]
SG[24]
SG[25]
SG[26]
SG[27]
SG[28]
SG[29]
SG[30]
SG[31]
SG[32]
SG[33]
SG[34]
SG[35]
SG[36]
GR[1]
GR[2]
GR[3]
GR[4]
GR[5]
GR[6]
GR[7]
GR[8]
GR[9]
GR[10]
GR[11]
GR[12]
C48
NM
NM
NM
R13
54
1
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
F-
P1
P2
P3
P4
P5
P6
P7
P8
P9
P10
P11
P12
P13
P14
P15
P16
P17
P18
P19
P20
P21
P22
P23
P24
P25
P26
P27
P28
P29
P30
P31
P32
P33
P34
P35
P36
1G
2G
3G
4G
5G
6G
7G
8G
9G
10G
11G
12G
F+
C34
1000p/50
7
C46
S15/T15
36
VP1
S14/T14
35
37
S13/T13
S12/T12
S11/T11
S10/T10
S9/T9
34
33
GR[12] 32
GR[11] 31
S6/T6
S31
R68
SG[1]
S8/T8
VSS1
2.2k
SG[2]
41
S7/T7
SG[14]
8
100p/50
S18
29
54
2.2k
42
P71_INT1/T0HCP
28
GR[10] 30
S32
D9
C65
S19
GR[9]
RES#
SG[17]
1000p/50
SG[3]
P70/INT0/T0LCP/RMIN
GR[8]
7
SG[18]
57
C53
SG[4]
43
S5/T5
SG[15]
150k
SG[19]
58
SLR-343VC(NPQ)
R67
C54
44
S20
S4/T4
55
SG[20]
59
0.1u/50
S21
18
P07/AN7
TP17
27
S33
60
NM
SG[5]
17
P06/AN6
TP16
GR[7]
P17/INT3/T0IN
S28
*C44
45
GR[6]
6
S26
NM
S22
S3/T3
SG[36]
78
77
P10/SO0
S37
NM
TP15
P05/AN5
26
SG[16]
R57
PDC182A
NM
*C64
SG[6]
16
25
56
P01/AN1
*C43
46
GR[5]
P12/SO0
P11/SI0/SB0
S36
*R66
S23
S2/T2
S34
IC2
NM
NM
*R64
P04/AN4
S1/T1
2.2k
FLDC+(-18v)
*D8
SG[7]
15
24
79
80
NM
R100
NM
R4
NM
R99
NM
R106
NM
R5
NM
R98
560
R95
560
NM
R105
560
R93
560
R94
2.2k
R97
560
R91
560
R92
NM
R104
560
R89
560
R90
NM
R103
NM
R81
NM
R82
2.2k
R96
NM
R79
NM
R80
2.2k
R102
R101
NM
R44
NM
R59
C-(-22v)
NM
*C41
V+12
NM
*R60
NM
*C63
SG[8]
47
NM
23
GND
*R63
48
S24
GR[4]
P00/AN0
P16/INT2/T0IN
VDD1
*C40
GND
NM
NM
S25
P03/AN3
GR[3]
P14/SI1/SB1
*D7
20
P02/AN2
14
S0/T0
P13/SO1
NM
*R62
BLUE
*C38
19
13
22
12
5
10
21
11
S35
9
GR[2]
3
GR[1]
2
0.1u/50
V+12
1.5k
*R61
10u/50
C37
0.1u/50
C35
NM
R87
NM
R88
6
NM
*C36
GND
NM
*C62
1.5k
NM
*R58
SW3R3
R69
NM
C33
1000p/50
560
R85
560
R86
B
C42
GND
*D6
R70
0
R78
4
P15//SCK1
1u/16
1
NM
TP14
NM
*C29
NM
X1
*D10
NM
*C61
V+12
*R56
LED_FLoff(RED)
*C27
*D5
GND
NM
NM
C31
GND
*C39
TP13
C32
0.1u/25
C30
1u/16
C28
C26
100u/16
560
R83
560
R84
23V
100p/50
GND
NM
*R55
2
NM
HD(RED)
C25
GND
CN1
5
F
4
KEY1
NM
GND
100p/50
KEY_SENSE
3
R45
TP6
V3EV
2
2.2k
TP7
1
D4
C60
GND
R42
NM
*R18
V3EV
NM
NM
C22
2.2k
P5
SLR-343VC(NPQ)
100p/50
5
8
A
FLKY ASSY
(VWG2625 : BDP-51FD)
V1
VAW1094-A
GND
GND
GND
B
GND
SW3R3
VNF1142-A
2
C
GND
SW3R3
D
GND
NM
WHITE
NM
LED_HDMI(RED)
V+12
E
GND
C45
GND
Q9
DTC124EUA
GND
F
B
95
1
2
3
4
10.13 PSWB ASSY
A
C
B
PSWB ASSY
(VWG2613)
V+12
P_ON LED (BLUE)
NM
C996
0.1u/50
Q991
DTC124EUA
JP991
NM
V+12
4
KEY0
3
GND
2
LED_PON
1
GND
CN3
TP902
5
B
GND
VKN1236-A
NM
2
P_ON
C997
S991
1
VSG1024-A
TP903
C995
C994
1u/16
10u/25
C993
0.1u/50
TP901 C992
1.5k
100p/50
1.5k
R992
C991
D991
C
R991
SLR343BC4T(JKLM)
TP904
CN991
GND
TP905
1
GND
GND
D
E
F
C
C
96
BDP-05FD
1
2
3
4
5
6
7
8
10.14 CAPK ASSY
A
F
CAPK ASSY
(VWG2614 : BDP-05FD only)
Capacitance sense KEY
B
560
R1
560
R2
560
R3
V3EV
C6
OPEN/CLOSE
0.1u/16
C2
0.1u/16
C3
2700p/50
C1
V3EV
1u/6.3
NM
25
V3EV
SENSE
3
GND
4
KEY1
5
GND
R14
20
2.2k
21
C
VKN1374-A
19
R12
17
10k
GND
18
10k
R17
KEY assign
10k
10k
0.1u/16
R15
R16
C5
0.1u/16
R11
10k
C4
26
27
28
30
R18
R13
2.2k
22
KEY_SENSE
9
8
P0(0)
P2(6)
P2(4)
P2(2)
P2(0)
P3(2)
P3(0)
XRES
16
Resolution
15
7
14
6
13
5
560
12
4
560
R6
P1(7)I2CSCL/SPI_SS.
1
2
24
23
P0(1)
P2(7)
P2(5)
P2(3)
P2(1)
P3(3)
P3(1)
P1(5)I2CSDA/SPIMISO.
P1(3)SPICLK.
P1(1)CLK/I2CSCL/SPIMOSI.
Vss1
P1(0)DATA/I2CSDA.
P1(2)
P1(4)
P1(6)
3
11
2
10
<<
R4
560
R5
29
31
Vss2
P0(3)
P0(5)
P0(7)
Vdd
P0(6)
P0(4)
P0(2)
32
1
>>
CY8C20434-12LKXI
CN2
CN1
IC1
STOP
B
PAUSE
24 OPEN/CLOSE
23 Resolution
22 SKIP Rev
21 SKIP Fwd
20 PAUSE
19 STOP
D
R9
0
GND
V3EV
CN2
R7
100
R8
100
1
V3EV
2
GND
3
RESET
4
SCL
5
SDA
VKN1374-A
E
GND
F
F
F
97
BDP-05FD
5
6
7
8
1
2
3
4
10.15 AUJB ASSY (1/2)
VDD3R3
A
R10
Front,C,SW
0
IC1
5
3
INA
4
GND0
0.1u/50
2
47
Vcc
C11
NC
R1
1000p/50
C15
1
MCLK1
R23
OUTY
47
TC7SHU04FUS1
R7
GNDD
VCC5
D 1/2,2/2
VDD3R3
L_active
Open_Drain
4
GND0
13
47
1000p/50
C34
C40
100u/16
47
R9
D
D
MD
MODE 24
7 DGND
RSTB 22
8 DVDD
ZERO 21
9 AVDDR
AVDDL 20
10 AGNDR
AGNDL 19
11 VMIDR
VMIDL 18
10k
R54
D 1/2
D
MC
C58
6 DIFFHW CSBIWO 23
TC7SHU04FUS1
R65
430
10u/50
D
GNDD
C45
0.1u/50
12 VOUTRP VOUTLP 17
GNDD
NM
47
MUTEB 25
5 SCLK
R25
OUTY
47
R48
C59
13 VOUTRN VOUTLN 16
C46
AVDD 15
R66
10u/50
R56
14 AGND
D
INA
0.1u/50
3
C13
2
47
1000p/50
C17
R3
R47
MD/DM0 26
4 MODE8X
15
5
Vcc
MC/DM1 27
3 BCKIN
47
220
R34
MCLK1
IC3
NC
2 DIN
R32
R33
ML
R55
0
R46
10k
D 1/2
R12
BCK
47
ML/I2S 28
1 LRCIN
0
ADAT0
VDD3R3
430
IC6
220
R31
LRCK
R64
10u/50
12
R8
1
0.1u/50
C32
14
GNDD
C57
GNDD
TC7SHU04FUS1
NM
0.01u/16
C30
GNDA
47
B
0.01u/16
47u
C28
GNDD
MCLK2
R24
OUTY
R44
4
GND0
TP17
3
0.1u/50
C12
Vcc
INA
47
1000p/50
C16
5
NC
2
0.1u/50
C26
IC2
1
R62
4.7k
0
0
R2
XAMUTE
R52
C55
R11
D 1/2
VDD3R3
0.1u/50
WM8740SEDS
430
D
10k
NM
TP2
C9
C14
C6
C2
NM
4
C3
NM
MD
5
C4
NM
R238 0
ML2
6
C217
NM
0
MCLK
7
GND
8
10k
R57
10u/50
C51
0.1u/50
C53
10u/50
C43
0.1u/50
C49
C60
R67
430
10u/50
D
GNDA
1000p/50
C56
1 LRCIN
R36
47
R37
220
ML/I2S 28
R49
47
2 DIN
MC/DM1 27
R50
47
3 BCKIN
MD/DM0 26
R51
47
R239
NM
R240
NM
4 MODE8X MUTEB 25
R38
MCLK2
47
5 SCLK
GNDA
TP45
NM
C220
1000p/50
C219
1u/16
NM
C221
NM
R237
R236
V-12
GNDD
MODE 24
D
ML2
MC
MD
D 1/2
C62
6 DIFFHW CSBIWO 23
TP48
TP49
L4
D
7 DGND
RSTB 22
8 DVDD
ZERO 21
9 AVDDR
AVDDL 20
10 AGNDR
AGNDL 19
11 VMIDR
VMIDL 18
R69
430
10u/50
D
GNDD
C47
0.1u/50
12 VOUTRP VOUTLP 17
C63
13 VOUTRN VOUTLN 16
14 AGND
GNDD
C48
AVDD 15
VDD3R3
R70
10u/50
0.1u/50
WM8740SEDS
R20
E
430
10k
220
R58
0.1u/50
C18
C10
DTF1070-A
TP34
TP35
TP36
TP37
TP38
TP39
TP40
BCK
R35
0
27
0
26
V-12A
R28
V-12A
ADAT1
D 1/2
0.1u/50
25
LRCK
TP44
0.1u/50
GND
GNDD
V+12
L3
R68
10u/50
DTF1070-A
C19
24
C20
23
100u/25
22
V+12A
C7
100u/16
TP16
GND
V+12A
C8
100u/16
TP15
L2
C61
GNDD
IC7
D
21
GNDA
V+5E
DTF1070-A
10k
XAMUTE
GNDD
XAMUTE
R59
20
0
D
19
V+5E
TP13
ADAT0
430
D
10k
ADAT0
TP12
ADAT2
R60
18
D 1/2,2/2
ADAT3
R63
4.7k
R53
Open_Drain
R45
17
Front L,R
TP18
16
GND
Ls,Rs
0
XAMUTE
100u/16
GND
ADAT2
TP11
Lb,Rb
0
R19
C41
15
0
R18
C37
ADAT3
R17
L_active
0.1u/50
14
ADAT1
VDD3R3
C33
13
GND
VCC5
0.01u/16
ADAT1
C,LFE
0
C31
12
D 1/2
BCK
R16
0.01u/16
TP10
GND
LRCK
C29
TP9
0
11
0.1u/50
TP8
0
R14
47u
BCK
R13
C27
10
ML2
10k
9
GND
D 1/2,2/2
D 1/2,2/2
VDD3R3
0
TP7
LRCK
MD
R29
TP6
0
R22
R27
TP5
TP81
A 10/10 CN8901
NM
ML
3
TP4
TP14
NM
R40
GNDD
R21
ML
MC
TP3
D
330p/50
C36
NM
2
VDD3R3
0.01u/16
GND
0.1u/50
1
C35
R26
TP1
V+3D
100u/25
VKN1617-A
L1
CN1
DTF1070-A
TP43
C
D
VDD3R3
INA
TP74
MC
4
GND0
OUTY
D 1/2,2/2
D
R61
10k
NM
10u/50
NM
R41
C52
330p/50
C39
0.1u/50
C54
NM
3
NM
C24
0
Vcc
C22
2
10u/50
5
NC
R6
C44
C38
1
0.1u/50
C50
NM
IC4
C64
GNDD
R71
430
10u/50
D
GNDA
NM
TP75
R15
IC22
NM
0
1
GNDD
5
VIN
VOUT
D1
NM
2
VSS
4
ON/OFF
IC5
NJM78M05FA
NC
IN
OUT
1
2
D3
VCC5
VDD3R3
R30
D2
NM
NM
R42
VCCMUTE
V+5E
0
1SS355
D4
TP76
1SS355
TP77
4
VNE1948-A
GND4
GND2
TP78
VNE1948-A
TP79
D 1/2
BDP-05FD
3
4
2
GND4
GND2
GNDA
2
GND3
GND1
GNDA
98
3
1
GND3
2
GNDA
1
KN4
3
TP47
0
F
KN3
1
GND1
R43
C42
NM
C25
100u/16
C23
C21
C1
NM
C5
470u/16
TP46
0
R39
NM
VCC5
0
0.1u/50
R5
3
R4
GND
V+12
V+12
47u/16
3
4
5
6
7
8
A
D 1/2 AUJB ASSY
(VWG2615 : BDP-05FD)
(VWG2632 : BDP-51FD)
VCCMUTE
Q3
C79
*JA1
2
1
100u
C84
C109
Lch
Front
Rch
NM
C105
100u
R117
R125
R135
220
220
GNDA
R136
R127
A_ALOUT2
C
220
220
Q7
2SD2114K(VW)
Q8
2SD2114K(VW)
1k
GNDA
C77
1
NM
D
1.3k
2
TP23
22p/50
1k D
C98
R101
*JA2
A_AROUT1
47u/25
R126
D
7
NM
Q6
2SD2114K(VW)
C118
1k
C114
7
IC12
4 NJM5532MD
5
4
5
Front
1k
C119
680
8
8
TP52
TP53
R109
C68
1200p
Q5
2SD2114K(VW)
TP21
A_ALOUT1
TP22
6
R93
150
NJM5532MD
R123
22p/50
V-12
6
IC9
220
NM
430
D
R134
220
C120
D
C67
R87
430
10u/50
D
D
150
1k D
C102
D
1.3k
R75
R67
R105
GNDA
C92
4
D
10k
R57
GNDA
C60
0.1u/16
100u
C91
C83
8
3
R92
1200p
D
2
1
D
10k
R56
430
0.1u/16
NJM5532MD
D
GNDA
R113
R74
R66
R122
TP41
1200p
430
C113
R124
IC9
C59
B
47u/25
NJM5532MD
V-12
GNDA
VWG2632 : BDP-51FD
VKB1159-A
VKB1159-A
VKB1130-A
VKB1265-A
V+12
C74
10u/50
GNDA
IC12
22k
R108
100u
C90
V-12
1
JA1
JA2
JA3
JA4
TP66
1200p
0.1u/16
4
3
C73
0.1u/16
IC8
NJM5532MD
4
R116
D
1.3k
D
8
3
100u
C89
100u
R104
GNDA
1
C82
430
2
TP50
TP51
D
1k D
C97
8
16
22p/50
22p/50
C66
2
0.1u/16
R91
150
R73
D
1k D
C101
D
150
C81
V+12
680
R86
R65
430
1200p
C58
10u/50
R112
R90
D
R55
10k
GNDA
GNDD
D
1.3k
4
5
VWG2615 : BDP-05FD
VKB1160-A
VKB1160-A
VKB1129-A
VKB1138-A
V+12
R100
7
C110
D
D
430
C65
D
1200p
430
10k
R54
D
10u/50
8
C106
6
R72
R64
C117
1200p
IC8
NJM5532MD
C57
0.1u/16
GNDD
NM
GNDD
R120
GNDD
10k
TP70
22k
1000p/50
C55
Q1
2SC4081(QR)
R98
1/2
R84
R62
4.7k
3.3k
2SA1576A(QR)
XAMUTE
1200p
R128
1k
R129
R137
220
220
RED3
9
TP25
TP24
6
TP26
Q4
2SA1576A(QR)
D 2/2
RED1
A_ASRR2OUT
3
10k
TP71
TP28
1200p
100u
D
430
D
5
NM
100u
C111
0.1u/16
Q9
2SD2114K(VW)
NM
R131
C121
22k
R118
2T
1
1k
C78
100u
C96
C88
22k
R119
Q10
2SD2114K(VW)
R139
220
220
R103
1.3k
D
NM
1k
R133
1T
7
IC13
4 NJM5532MD
LFE
*JA4
TP42
TP30
8
Center
C116
E
GNDA
47u/25
22p/50
7
4
3
C122
100u
C95
C87
8
5
D
1k D
C100
C72
6
NJM5532MD
TP56
TP57
R97
150
IC11
6
R111
R89
D
220
22p/50
V-12
R79
R71
430
D
150
1k D
C104
D
1.3k
R96
1200p
C64
10u/50
GNDA
R107
GNDA
4
D
R61
10k
GNDA
R138
220
R132
R115
8
0.1u/16
3
D
680
430
C71
D
R130
2
1
1200p
430
2
R78
10k
R60
D
10u/50
C115
47u/25
V-12
GNDA
IC11
NJM5532MD
C107
22p/50
R110
100u
V-12
1200p
R70
GNDA
NJM5532MD
V+12
C76
C63
1
IC13
TP67
1200p
C94
4
0.1u/16
3
C75
0.1u/16
IC10
NJM5532MD
4
TP29
D
1.3k
D
8
3
100u
C93
R106
GNDA
1
2
TP54
TP55
D
C86
430
8
0.1u/16
R95
2
D
GNDA
22p/50
1k D
C99
C70
R77
D
C85
680
R88
R69
430
D
150
150
1200p
C62
10u/50
1k D
C103
R94
V+12
D
10k
R59
GNDA
GNDD
R114
D
C108
D
TP31
TP32
TP33
V+12
R102
1.3k
C112
4
D
430
C69
D
1200p
430
8
5
7
10k
R58
D
10u/50
6
R76
0.1u/16
IC10
NJM5532MD
R68
Surround back
1
*JA3
C80
C61
2
WHT1
GNDD
R121
GNDD
GNDD
Surround
4
TP27
A_ASRL2OUT
1000p/50
C56
Q2
2SC4081(QR)
R99
R85
4.7k
5
WHT2
A_ASRL1OUT
3.3k
1/2
R63
Front
7
WHT3
RED2
A_ASRR1OUT
VCCMUTE
XAMUTE
8
A_AROUT2
GNDA
1200p
R80
0
KN4
D3
GND1
D4
GND2
GND3
0
R82
4
2
TP78
R81
3
1
GND4
0
VNE1948-A
R83
TP79
F
TP80
0
GNDA
GNDD
GNDA
D 1/2
99
BDP-05FD
5
6
7
8
1
2
3
4
10.16 AUJB ASSY (2/2)
A
Surround
VCCMUTE
VCC5
VDD3R3
Q11
2SC4081(QR)
C151
1000p/50
C137
100u/25
C131
0.1u/50
C129
0.01u/16
C127
0.1u/50
0.01u/16
47u
3.3k
4.7k
0
C125
R168
R158
@NoteNet
C123
R186
2SA1576A
D 1/2
XAMUTE
TP72
GNDD
C175
GNDD
1200p
IC16
6
NJM5532MD
R170
0
47
R143
5 SCLK
MODE 24
MD
D 1/2
C154
6 DIFFHW CSBIWO 23
RSTB 22
8 DVDD
ZERO 21
9 AVDDR
AVDDL 20
10 AGNDR
AGNDL 19
11 VMIDR
VMIDL 18
R171
430
10u/50
TP19
7 DGND
GNDA
D
IC16
D
NJM5532MD
C169
1200p
IC17
2
NJM5532MD
C155
R172
430
D
D
430
1
4
R194
150
680
R189
V-12
R195
C156
GNDD
C164
150
6
8
7
R181
R173
430
10u/50
1200p
D
GNDA
10k
R163
C149
10u/50
C147
0.1u/50
10u/50
NM
C139
R148
8
3
C163
R162
D
10u/50
R180
10k
C142
0.1u/50
C145
NM
V+12
1200p
0.1u/50
330p/50
V-12
C170
0.1u/50
WM8740SEDS
C133
1
4
C141
AVDD 15
C132
8
3
GNDD
13 VOUTRN VOUTLN 16
C
R193
R179
430
12 VOUTRP VOUTLP 17
14 AGND
150
150
2
D
MCLK1
MC
V+12
680
47
R192
R188
R154
MUTEB 25
C161
MD/DM0 26
4 MODE8X
C162
MC/DM1 27
3 BCKIN
7
4
5
1200p
2 DIN
47
D
1200p
220
R153
ML2
8
R178
430
10k
R142
47
R160
47
R152
D
D
R141
ML/I2S 28
1 LRCIN
R161
BCK
220
R150
ADAT2
D 1/2
R140
D
10u/50
IC14
LRCK
430
D
C153
1200p
GNDD
10k
GNDA
B
D
IC17
D
430
4
5
NJM5532MD
GNDA
C173
1200p
VCCMUTE
D
VCC5
VDD3R3
R169
4.7k
3.3k
D 1/2
R187
2SA1576A
XAMUTE
R159
@NoteNet
Q12
2SC4081(QR)
C152
C138
100u/25
C134
0.1u/50
C130
0.01u/16
C128
0.1u/50
0.01u/16
C126
47u
C124
1000p/50
0
TP73
GNDD
C176
GNDD
1200p
IC18
6
NJM5532MD
R174
R156
47
MD/DM0 26
R157
47
0
MUTEB 25
MODE 24
C158
6 DIFFHW CSBIWO 23
ZERO 21
10u/50
AVDDL 20
AGNDR
AGNDL 19
0.1u/50
11
VMIDR
VMIDL 18
12
VOUTRP VOUTLP 17
13
VOUTRN VOUTLN 16
AGND
D
C165
D
430
IC18
NJM5532MD
C172
IC19
C144
R176
10u/50
V-12
V+12
430
D
430
D
3
R177
430
D
C168
R191
10u/50
150
V-12
R199
150
6
8
R185
430
D
IC19
NJM5532MD
GNDA
1
4
R198
1200p
GNDA
C160
GNDD
8
R184
10k D
R167
10u/50
C148
0.1u/50
C150
10u/50
NM
C140
R149
0.1u/50
C146
NM
2
NJM5532MD
C159
0.1u/50
330p/50
1
4
1200p
AVDD 15
C136
8
C171
WM8740SEDS
C135
3
1200p
10
14
D
GNDD
C143
9 AVDDR
R197
150
2
D
RSTB 22
8 DVDD
150
R183
R175
430
R166
7 DGND
TP20
E
GNDA
680
5 SCLK
D 1/2
C167
47
MD
1200p
R147
MC
V+12
680
MC/DM1 27
3 BCKIN
R196
R190
2 DIN
220
C166
47
R146
ML2
7
4
5
1200p
R145
4 MODE8X
MCLK2
47
10k
R155
D
430
D
ML/I2S 28
8
R182
D
10k
1 LRCIN
R165
BCK
220
R151
ADAT3
D 1/2
R144
R164
IC15
LRCK
D
10u/50
430
1200p
C157
GNDD
10k D
GNDA
5
7
4
C174
1200p
F
D 2/2
100
BDP-05FD
1
2
3
4
5
6
7
8
VCCMUTE
Q13
TP72
R200
Q11
2SC4081(QR)
C175
1200p
100u
C201
Q15
2SD2114K(VW)
C213
NM
Q16
2SD2114K(VW)
NM
R225
A_ASRL1OUT
C214
22k
R218
22p/50
220
Surround Lch
1k
D 1/2
100u
C187
100u
C188
0.1u/16
C180
6
NJM5532MD
D
1.3k
220
A_ASRR1OUT
Surround Rch
C
47u/25
NJM5532MD
22p/50
1k D
C194
R203
7
4
5
R211
8
R233
220
C210
7
4IC20
5
D
150
6
8
TP60
TP61
R195
181
R227
GNDA
22p/50
D
150
D
1k D
C198
D
1.3k
V-12
680
R189
C163
1200p
C164
1200p
R207
GNDA
4
R194
IC17
R232
220
1k
22k
1
R219
8
3
D
R224
R226
GNDA
R215
180
NDA
0.1u/16
C179
2
D
C209
47u/25
V-12
GNDA
1200p
IC17
GNDA
NJM5532MD
V+12
C170
NJM5532MD
100u
V-12
1
IC20
TP68
1200p
4
100u
100u
D
C186
C169
0.1u/16
C178
NJM5532MD
0
C185
GNDA
1
4
3
8
3
R210
8
R206
1.3k
IC16
2
TP58
TP59
D
1k D
C193
2
B
22p/50
R193
150
D
0
0.1u/16
C177
D
680
R188
D
150
C205
1200p
C161
C162
V+12
R179
0
1k D
C197
R192
1200p
NDA
GNDD
R214
D
1.3k
4
5
0.1u/16
D
V+12
R202
7
C206
8
C202
6
0.1u/16
IC16
NJM5532MD
R178
NM
GNDD
R222
GNDD
10k
3.3k
R186
2SA1576A(QR)
0
A
D 2/2 AUJB ASSY
(VWG2615 : BDP-05FD)
(VWG2632 : BDP-51FD)
GNDA
C173
1200p
VCCMUTE
Q14
3.3k
TP73
C176
1200p
C168
1200p
NDA
IC19
D
680
5
C207
C203
0.1u/16
100u
Q17
2SD2114K(VW)
C215
NM
R229
A_ASRL2OUT
Q18
2SD2114K(VW)
NM
220
C216
TP69
22k
R220
100u
1k D
C195
C208
100u
100u
C190
0.1u/16
R234
220
Surround back Lch
E
1k
D 1/2
8
C191
100u
6
TP64
TP65
5
D
R205
7
1.3k
4
R231
R235
220
220
GNDA
A_ASRR2OUT
Surround back Rch
22p/50
R199
R185
D
D
150
1k D
C200
D
1.3k
150
NJM5532MD
R209
GNDA
V-12
6
R228
1k
22k
1
4
R198
R191
C167
1200p
3
GNDA
R221
8
184
D
C211
47u/25
R230
R213
NJM5532MD
GNDA
NJM5532MD
R217
100u
2
C184
IC19
1
IC21
V+12
0.1u/16
C172
4
V-12
GNDA
1200p
0
D
V-12
C183
1200p
C192
NJM5532MD
4
C171
0
C189
GNDA
1
8
3
R212
8
0.1u/16
3
C182
IC18
2
R208
1.3k
D
22p/50
TP62
TP63
D
150
2
0.1u/16
R197
C181
D
680
V+12
D
1k D
C196
C166
1k D
C199
D
150
183
0
GNDD
R196
R190
C165
1200p
5
1200p
NDA
4
R216
D
1.3k
8
7
4IC21
C212
47u/25
NJM5532MD
22p/50
D
0
V+12
R204
7
C204
8
0.1u/16
6
22p/50
IC18
NJM5532MD
182
NM
GNDD
R223
GNDD
D
10k
Q12
2SC4081(QR)
R201
R187
2SA1576A(QR)
GNDA
C174
1200p
F
D 2/2
101
BDP-05FD
5
6
7
8
1
2
3
4
3
4
10.17 SYPS ASSY
A
B
SYPS ASSY
(VWR1415)
TO AC POWER CORD
G
T4AH250V
C
D
[CAUTION - FOR CONTINUED PROTECTION AGAINST
RISK OF FIRE, REPLACE WITH SAME TYPE NO.(A) MFD.
BY LITTELFUSE INC. FOR (B).]
(A)
(B)
49101.5 P101
491.630 P201, P271, P501
491004. P301, P401
491.315 P601
E
F
G
102
BDP-05FD
1
2
A 8/10 CN7001
A 8/10 CN7002
TO DRIVE
5
5
6
6
7
7
8
A
G
BDP-05FD
8
103
B
C
D
E
F
1
2
3
4
10.18 WAVEFORMS
A
Note : The encircled numbers denote measuring point in the schematic diagram.
A
MAIN ASSY
1
27 MHz VMCLK
R1141_IC1001
P-ON
2
36.864 MHz AMCLK1
R1143_IC1001
P-ON
3
33.8688 MHz AMCLK2
R1142_IC1001
P-ON
4
Video Out
IC6001_27pin
75% Color-bar A1 Disc 2-20
5
Y Out
IC6001_25pin
75% Color-bar A1 Disc 2-20
6
C Out
IC6001_29pin
75% Color-bar A1 Disc 2-20
7
Component Y Out
IC6001_23pin
75% Color-bar A1 Disc 2-20
8
Cb Out
IC6001_21pin
75% Color-bar A1 Disc 2-20
9
Cr Out
IC6001_18 pin
75% Color-bar A1 Disc 2-20
B
C
D
E
10
CoAxicial Out
C8111_+ side
1kHz 2Vrms A1 Disc 2-1
11
Optical Out
R8206_JA8001 side
1kHz 2Vrms A1 Disc 2-1
F
104
BDP-05FD
1
2
3
4
5
6
7
8
A
D
12
AUJB ASSY
LRCK
IC6_1pin
1kHz 2Vrms
13
BCK
IC6_3pin
1kHz 2Vrms
14
ADATA0
IC6_2pin
1kHz 2Vrms
B
15
16
MCLK
IC6_5pin
1kHz 2Vrms
LOUT
IC12_1pin
1kHz 2Vrms
C
D
E
F
105
BDP-05FD
5
6
7
8
1
2
1
2
3
4
3
4
A
B
C
D
E
F
106
BDP-05FD
5
6
7
8
11. PCB CONNECTION DIAGRAM
NOTE FOR PCB DIAGRAMS :
1. Part numbers in PCB diagrams match those in the schematic
diagrams.
2. A comparison between the main parts of PCB and schematic
diagrams is shown below.
Symbol In PCB
Diagrams
Symbol In Schematic
Diagrams
B C E B C E
Part Name
3. The parts mounted on this PCB include all necessary parts for
several destinations.
For further information for respective destinations, be sure to
check with the schematic diagram.
4. View point of PCB diagrams.
Connector
A
Capacitor
Transistor
B C E
B
C
E B
C
SIDE A
E
Transistor
with resistor
B C E
D
G S D
G S
B
Field effect
transistor
D G S
P.C.Board
Chip Part
SIDE B
Resistor array
3-terminal
regulator
C
D
E
F
107
BDP-05FD
5
6
7
8
1
2
3
4
11.1 MAIN ASSY
SIDE A
MAIN ASSY
L5105
5
L5109
L5106
L5107
L5108
Q5221
F5010
1
F5009
1
F5008
1
Q6402
Q5201
25
Q6401
20
1
1
15
10
IC5301
5
1
1
E
1
10
10
D5312
E
5
15
20
20
IC6001
1
D6206
15
E
C5407
10
5
1
E
E
E
IC3831
1
IC3841
IC3801
X3801
C1401
E
C7313
L6303
C6307
L3801
C7106
C1442
S
E
1
1
C1441
1
1
IC3201
IC3299
IC7101
C3202
IC1001
D3151
C3802
1
F3801
TH8801
1
11
C7103
IC3151
1
GND
SW+5V
SW+5V
GND
EV+6V
P-ON
GND
SW+12V
GND
SW-23V
GND
S E
F3101
1
5
1
1
E
Q8701
1
1
1
1
1
1 1
15
1
151
1
1
1
1
D
35 1
25
1
C3102
1
1
5
10
CN7002
F3201
AA
MAIN ASSY
1
VNP2080-C
1
1
CN7001
1
AA
5
1
15
CN7002
1
1
30
11
G CN201
1
20
20
G CN202
1
1
IC3101
IC3199
CN1501
S4452
10
20
30
40
CN1501
CN9001
ATAB ASSY
VWV2360
15
20
25
30
35
40
CN9003
TO DRIVE
10
G ]]
A30C5/C7
CN9003
15
5
10
PC
35
25
20
A
5
LF
1
CN9002
1
CN9001
CONTACT BOTTOM SIDE [[
1
F
30
40
(VNP2080-C)
108
BDP-05FD
1
1
30
VWV2315
VWV2316
VWV2375
VWV2376
VWV2377
1
Q4313
Q4311
IC6301
1
IC3101
IC3199
IC4101
60
10
E
C
25
25
1
5
5
Q8701
20
15
1
GND
SW+2.5V
SW+2.5V
GND
1
5
1
1
GND
GND
SW+1.5V
SW+1.5V
GND
IC4203
IC4201
IC3151
IC4002
IC3501
IC4202
1
1
CN1301
10
1
IC1001
55
IC6302
L3802
SW-12A
GNDA
SW+12A
GNDA
1
1
50
CN7001
IC3201
IC3299
IC7101
1
1
1
Q6161
Q6151
Q6141
Q6131
Q6121
Q6111
Q7601
C7009
IC5801
1
1
Q7651
100
1
IC3801
95
10
1
IC3841
C7333
IC7311
D7311
5
D
90
C6204
L6304
D6207
D6208
E
IC3831
Q7601
15
L6001
D7331
E
IC2301
IC2399
C6001
10
Q7651
10
1
IC6302
5
45
IC6301
IC7311
1
40
Q6161
Q6151
Q6141
Q6131
Q6121
Q6111
85
C5010
35
C
IC6001
IC2351
IC2201
IC2299
C6203
D6205
5
JA3701
1
D6204
1
80
IC7331
1
1
C6201
50
CN8801
45
D5301
IC5801
1
D5311
20
75
25
70
30
D6211 D6212
65
D6209
D6210
1
Q6403
IC5311
D6202
CN8801 D6201
Q8171
IC7331
Q5211
IC5001
60
TO FAN
1
1
JA6002
40
C6206
35
C6205
55
IC5301
JA6001
1
IC5311
IC8001
IC8101
Q5201
Q6403
Q6401
Q8181
D6203
1
IC8031
Q5211
30
IC5001
IC4351
1
10
Q6402
B
1
F5007
JA5001
1
1
1
A
Q5221
CN6401
GND
Y
Y_GND
Pb
Pb_GND
Pr
Pr_GND
CTEL1
CTEL2
CTEL3
GND
5
1
1 20
A
5
Q
10
IC
15
A
2
3
4
5
6
7
8
SIDE A
A
This PCB is six layer structure.
1
CN1601
UPPER
10
JA8001
JA4351
1
D4351
IC4351
25
1
10 IC8031
20
E
15
B
5
1
15
5
CN8101
10
C8111
5
C8184
1
PC
1
5
1
KN1001
B
1
5
L4421
E
30
CN4601
1
25
A
15
1
10
L4408
1
5
L4403
1
1
1
1
1
1
35
40
45
50
55
A
30
1
1
1
IC3501
1
1
1
1
1
1
1
AA
11
1
5
10
15
1
1
X4001
1
20
D
C4415
25
1
E
D4101
S4452
Q4311
D4311 E
Q4313
E
IC4101
1
5
1
20
CN8901
IC4202
1
1
IC3101
IC3199
C3501
IC4203
IC4201
9
IC4002
25
CN42011
15
1
S E
F3501
CN4401
LED_HD
IR
V+5E LED_FLOFF
GND
GND
LED_PON GND
GND LED_BLUE
GND LED_HDMI
GND
V+3E
GND
GND
GND V+12SW
GND
V+3D
GND FLDATA
GND
FLCLK
GND
FLSTB
GND
KEY1
KEY0 V-23SW
10
1
IC2301
IC2399
V-12A
V-12A
V+12A
GNDA
GNDA
V+12A
V+5E
XAMUTE
GND
ADATA0
GND
ADATA2
GND
ADATA3
GND
ADATA1
GND
BCLK
GND
LRCK
AMCLK DAC_ML2
DAC_MDO
DAC_ML DAC_MC L8901
GND
V+3D
D CN1
5
A
CN8901
1
1
1
1
1
CN4401
SIDE A(SECOND)
1
1
E
S
11
IC1001
C
L4406
L4405
L4410
1
1
1
LF
IC2351
F2301
[[ G ]]
A30C5/C7
C2302
D2351
11
1
1
IC2201
IC2299
B CN1
20
C4408
CN4401
F8001
JA3701
5
Q8171
C2202
10
1
C8002
S
5
IC8101
E
C8174
1
5
IC8001
Q8181
30
C7503
1
E
(VNP2080-C)
F
A
109
BDP-05FD
5
6
7
8
1
1
2
3
4
SIDE B
A
IC
Q
A
MAIN ASSY
SIDE B
LF
Q5231
1
1
5
A
11
1
1
5
1
1
E
1
1
R1183
C1070
C1068
C1069 C1063
C1
C1048
A
11
35
40
45
30
25
C
R330
C3119
R1229 C3118
R1228
R1234 C3117
C3116
R4594
R1223 C3115
R4586
1
R3111
C3124
C3109
R4031
C3112
R4032
R4033
D6001
R4034
D6002
R4037
D6003 R4036
R4038
D6004
R4039
R4065 R4040
R4064R4041
R4042
20
C1
C1058
C1010
C1006
C1007
C1008
R1129
C1013
R1112
R1114
4
C1049
C1005 C1
R4210
R4209
R4057 R4208
R4068
IC4001
R4049 C4022
C1
C1
C1004
R1002
R1001
C1062
R1243
1
1
1
1
1
E
E
1
10 10
C1449
R1113
1
5
5
5
CN4401
1
1
R2111
C2114
C2118 R2112
C2117
C1040
C1039
CN8901
C5324 C2115
C2116
R1128
R1120
C1018
3
R4588
R4052
R4051
BDP-05FD
2
R1003
15
A
1
C1036
C1057
C4020
10
F
110
C1038
C1037
R4048
C4011
60
C4004
C4003
R4223
D4002
D4001
R4045
R4044
R4043
5
C1041
R1244
C1011
R1127
R4058
1
R1
C1067
C1061
C1071
R4069
55
F4001
C4021
R4026
R4596
R1216
50
R4018
C1424
R1442
C1012
R4047
R4015
C142
C142
R1218
R1215
R1231
C1089
C1088
F1421
C1072
R1217
R4046
R4589
R1233
E
C1026
C5807
C5804
C1024
C1023
C1065
C1021
C1022
C1020
C1014 C1064
C1066
C1019
C1091
C1016
C1015
C1017
R1130
C4016 C4014
R4019
1
R4022
R4020
C4018 R4021
R4059
C4002
C4221
Q4004
E
R1236 R1235
R1241
R1137
R1239
Q4003
R1232 R4013 R4595
Q4002
R1134 R4014
R3511
C4001
C1029
C1027
C1025
C1402
R4224
R3503
C1035
1
R1004
C1056
C1404
C1403
Q4001
R3596
C3507
Q8812
C2407
R3510
R3502 R3501
IC3551
Q4003
R4225
C4222
R3505
R3509
C1045
C1044
C1043
C1042
C1033 C1031
1
C1032
C1028
C1205
R1212
F1401
C1209
C2409
C2408
R2634
R3591
C1034
C2413
C2414
R2622
R2620
C2606
C2608
C1405
R3593 R3592
R3594
Q4001
Q4002
IC5321
R2640
C2607
R2635
C2410
C2411
C6329
R3508
C1621
C1211
R3597
IC1621
R1624
C8932
R1622
C8923
C6328
R1621
C8927
C5321
R5321
IC7501
R2638
R2642
R2644
C8904
C8929
C8928
Q8702
Q8801
Q8811
Q4004
IC4001
D7501
C2106
C2105
C2104
C2103
D2151
1
C2604
C8921
R2636
C8931
C3701
R8201
R2151
C2416
R2615
R4221
R3504
R3555
C4223
R3512
R3552
R4222
R3513
R3553 R3551 R3506
C3506
R3554
E
R2625
C1030
R1623
IC3361
C2412
R3792
R1402
C2113
C1421
C2112
IC2101
IC2199
IC2661
R2662
R2661
IC2401
IC2499
C8926
C8925
IC7201
1
1
E S
R2619
C8930
C8922
C2107
R2645
R2647
R2643
1
C8903
C8924
C2109
C2108
R2639
R2637
E
S
C2403
C2404
C2405
C2406
IC3861
IC1621
R2641
C2415
C4416
1
R5322
Q52
R5237
R523
F3
C2110
C2151
C5322
C5323
C7501
R2411 R2412
C2418 C2417
L4404
C4417
Q6505
1
C2102
C2402
R8921
IC2401
IC2499
C8012
C8011
C4406
C4407
L4402
R8203
C8201
R8202
R8015
Q8201
R8014 C2152
IC2151 F2101
C2111
C2605
L4407
Q6503
Q6504
IC3551
IC7301
IC8801
R8036
R2152
C2603
C4411
C4410
L4412
D5321
R2153
C2602
IC2601
L4411
L4414
C4420
Q6501
IC3301
R8049
R4404
L4413
IC5401
IC7421
Q6502
R8040
L4417
R4403
C4421
IC2101
IC2199
IC2661
D
R4351
L4415
IC5803
IC2601
IC5802
C4351
R8006
C2601
IC5812
C
C4419
L4416
C4418
IC2151
Q8201
Q5035
Q6002
C4423
IC5811
R8205
R8204
IC8011
C2153
R2154
R8039
Q5232
Q6404
Q6405
Q5311
R8051
R8043
R8044
IC5321
IC7501
R8005
Q5202
R4581
R4582
IC8011
R8045
R8047
B
C3
C312
C3
R3333
5
6
7
8
SIDE B
A
This PCB is six layer structure.
SIDE B(FIRST)
LF
C8806
R6001
R6003
R6005
R6007
C6008
1
1
1
1
C8802
R8816
1
C
C7656
1
C7424
D7421
R7321
R6021
R6022
C7322
R6019
R6020
C6011
C6016
C6012
C6013
C6014
C6015
IC7421
C7655
C7652
1
C7651
C6503
R6512
Q6503
R6511
R6510
C7657
C7323
R1338
C7601
R1337
C6505
R6520
Q6505
R6519
R6518
R6517
C7606
R1336
C7421
R7001
10
R3867
D7201
C7205
R7206
R7201
C7008
C3301
R8804
R8807
R8806
R8801
D7301
5
5
1
15
R8803
1
R7302
R8805
C7302 IC7301
C7304
R8802
IC8801
D
C7201
C7202
IC7201
C3862
1
C7303
R3866
R3863
C3866 IC3301
1
C3861
C3864
R3862
C3869
C3868
R3861
R7204
C3863
R7205
C7602
C7002
C7203
1
R3864
C7301
C7305
R7303
R7301
R1523
E
R1522
5
1
E
C7005
E
1
E
1
1
R1514
Q8801
R8808
Q8702
R8713
R8811 R8812 Q8811
R1515
R7501
R1516
R1517
C8801
1
C3308
C7605
C7204
R3868
C3224
R3211
C3304
C3306
C3307
C7607
X3861
IC3861
C3867
R3212
C3223
R3865
C3865
C3305
L8801
R6002
R6004
C6018
R6006
R6008
C5006
C5007
C5008
L6302
C6501
R6504
Q6501
R6337 R6503
R6338 R6502
R6501
F1431
C1431
C3217
1
1
C7422
E
C3222
1
R6024
Q6002
R6208
C6010
R6204
1
1
Q6405
Q6404
R6401
C5009
C6009
C3871 C3870
C3216
C3218
C3220
C3219
C3221
C3302
C3303
R1520
R1518
C1502
C8803
R1335
E
C3211
R3361
1
1
Q8812 R8821 R8815
R8813
R8814 D8801 C8804
C8805
CN1501
(VNP2080-C)
ATAB ASSY
LF
CN9003
R4031
C3112
R4032
R4033
D6001
R4034
D6002
R4037
D6003 R4036
R4038
D6004 R4039
R4065 R4040
R4041
R3362
R3363
R1101
R1103
C3113
R1106 R1102 R1104
C3111
R1609R1222
C3110
C3108
C3107
R1108
R1109
R1107
R1118
R1112
R1114
C3119
R1229 C3118
R1228
R1234 C3117
C3116
R4594
R1223 C3115
R4586
R1242
R3112
C3123
C3122
C3121
C3120
C3114
R3333
R6509
E
C3210
C3213
C3214
C3212 R3334
R3303
R3307
C1008
R1129
C1013
R3306
C1432
C3215
C3209
R3311
C7423
E
C1434
C1433
C1435
C1446
C1090
C1058
C1010
C1006
C1007
R1128
C3109
R6525
R3304
R4210
R4209
57 R4208
C3208
R6521
R6522
R6523
R6524
1
B
1
R6023
R7423
C7425
R7421
A
B
C
0 1 2 3 4 5 6 7 8 9
F5002
R1334
C3207
C1445
IC3361
1
C6325
C5406
C6504
R6516
Q6504
R6515
R6514
R6513
R1441
C1004
R1002
R1001
C1062
R1243
C1009
1
R5313
C5313
C6304
E
C6502
5 C5408
C5409
R6508
Q6502
IC5401 R6507
R6506
R6505
C1083
C1408
C1407
C1409
R1401
R1183
C1068
C1069 C1063
C1070
R1003
C1051
C1049
C1005 C1054 C1052
C1053
C1055
C1002
C1003
C1001
R3111
C3124
Q5311
C5061
C5403
1
C5414
C5413
R1164
C1449
C1040
C1039
C1038
C1047
C1050
R1244
C1011
C6305
R6320
C6302
R6319
R6309
C5003 C5401
C6306
C5004
C6303
R5405
R5406
R1198
C5412
R5401
R1173
R1174
R1168
C1045
C1084
C1085 C1081
C1082
0
R6308
1
C1046
C1048
C5002
R6347
R6348
R5039
R5025
R5038
L5401
C5402
R5408
C5405
1
C5005
C5054
C5012 R5015
C5404
0
0 1 2 3
R5312
1
R5314
C5001
R5022
15
10 10
R1199
R1197
C1041
C1012
R4588
R5037
C1447 C1448
R1145
C1067
C1061
14 C1064
091
C5055
L6301
R1165
R1442
L5061
C5062
F5003
F5001
1
R5023
C5806
C5803
C1422
C1423
C1087
C1086
C5053
R5024
R1201
R1196
F1421
72
R5804 R5805
20
R1171
R1166
R1163
5
10 R1172 R1162
R1169
IC5803 R1167
2020 15
5
IC5802
C1089
C1088
C1424
C5057
C5056
C5051
C5049 C5048
C5052
L5051 C5047 C5046
R5311
C5045
C5050
R6410
C5065 L5062
C5064
R5035 L5052
C5066
R6413
R5036
C5063
Q5035
R5062
5
1
C3702
1
R2111
C2114
C2118 R2112
C2117
IC5812
1
C5324 C2115
C2116
C5807
C5804
E
5
R5240 1
R5232
IC5811
C5811
R5801
R3791
R3792
R5034
Q5232
R5237
R5239
F3701
R1402
C2113
C1421
C2112
58
Q5202
1
IC5321
2
C5322
C5323
C3701
21
R5033
Q5231
R5235
R5206
R5231
R5236
R5233
R5234
R5238
F
A
(VNP2080-C)
111
BDP-05FD
5
6
7
8
1
2
3
4
11.2 FLKY, CAPK and PSWB ASSYS
SIDE A
A
FLKY ASSY
D5
D7
D
PSWB ASSY
CN991
CONTACT SIDE
CN991
1
5
1
5
C994
[[ G ]]
C7
E
D991
J901
PC
PWSB
POWER
JP991
1/2
S991
(VNP2106-A)
F
B C
112
BDP-05FD
1
2
3
4
GND J
J43
D10
D6
C
C
C26
J11
J12
J14
J15
J57 GND
J62 GND
J61 GND
J54 GND
GND
GND
J2
D4
FL OFF
J5
J8
J1
J7
X1
J16
J17
J18
V+12
J56
HD
GND
C37
V5EV
IC1
D3
J4
C6
1
FLDC+
J3
V+12
J64 GND
J58 GND
J19
V+12 J10
GND
J6
J23
J13
JP3
1
CONTACT SIDE
50
CN3
45
CN3
40
5
IC1
35
1
5
30
1
25
JP1
20
B
15
B
Q
5
IC
5
6
7
8
SIDE A
A
GND
J52
GND
J53
GND
S3
S2
OPEN/CLOSE
Resolution
S6
S4
SKIP fwd
SKIP rev
J65
FLDC+
V+12
V+12
S1
JP5
S7
STOP
PAUSE
J31
J32
C7
V-22
J35
D9
GND
J36
J34
R4
GND
V-22
C13
C
C18
J39
J51
J38
J42
C16
GND
C10
J47
GND
GND
J49
J9
J48
GND
J59
J50
GND
J41
GND
GND
JP4
J44
5
CN2
J37
5
1
JP2
J63 GND
CONTACT SIDE
1
J45
R5
PC
J60
D8
R13
J33
GND
J27
J30
J29
J28
J26
GND
GND J20
J21
J22
J40
B
JV1
PLAY
S5
SIDE UP
CN110CONTACT
30
20
30
1
5
15
25
1/2
1
CN2
CN1
A
(VNP2106-A)
D
CN4401
BDP-05FD Only
IC
Q
F
CAPK ASSY
1.V3EV
2.GND
3.RESET
4.SCL
5.SDA
1.V3EV
2.SENSE
3.GND
4.KEY1
5.GND
C6
5
C1
R5
R4
C5
R18
1
E
B
R2
R3
C2
C3
C
PC
15
R6
10
IC1
R8
R7
R1
R9
1
/5
CN1
R13
R14
R17
R12
R15
R16
R11
VWG
30
CN2
25
[[ G ]]
A30C5
CAPK
1
5
1
20
IC1
5
C4
CN1
LF
J16
J17
J18
FLKY
VWG2614
J43
[[ G ]]
C7
A
J11
J12
J14
J15
6
J24
J25
KN1
GND
5
1
V1
(VNP2108-A)
F
F B
113
BDP-05FD
5
6
7
8
R103
V3EV
KEY_SENSE
GND
KEY1
GND
(VNP2108-A)
R99
1
2
3
4
5
BDP-05FD Only
R101
C38
R7
C11
C12
C72
C50
C71
E
C64
C27
Q5
Q8
Q9
R54
C15
C51
CN1
R102
C40
R62
R56
R55
C9
R51
C56
R30
R71
R23
R8
C55
C69 R3
1 LED_HD
2 IR
3 V5EV
4 LED_FL OFF
C73
V-22
R21
5 GND
6 GND
7 LED_PON
8 GND
R43
B F
R63
C39
C29
R67
R11
R10
E
E
Q2
R24
R27
R33 17 GND
9 GND
10 LED_BLUE
11 GND
R28 12
LED_HDMI
13 GND 23 GND
R25 14 V3EV 24 FLCLK
15 GND 25 KEY0
26 FLSTB
16 GND
27 GND
28 KEY1
29 KEY0
30 V-23V
R32
R39
18 V+12
R38
19 GND
20 SW3R3
21 GND
22 FLDATA
F
C41 Q7
Q6
C43
R68
R64
C46
R36
R15
R17
C8
D1
R9
R12
D2
C14
R52
R48
R46
C19
C34
C36
R58
R105
R65
R106
R66
R14
R16
R19
R53
R49
R47
R40
R75
4
3
E
E
R20
R26
FLDC+
R29
R41
R6
R74
BDP-05FD
114
R107
1
5
C58
C44
R34
R76
F
2
E
1
CAPK ASSY
F
1
5
15
R37
CN2
CN1
D
D
25
E
C52
CN1
10
20
30
C57
C66
C67
C68
C70
C20
C47
R73
R50
C42
R18
R72
E
C45
R22
C
C65
B
Q9 Q8
Q2
V-22
R77
Q3
R86
R85
E
Q1
Q6 Q7
Q4 Q5
Q1
R88
R87
R60
R104 R61
IC2
C49
H
R84
R83
G
B
FLKY ASSY
B
Q
IC
4
3
2
1
A
SIDE B
R35
C21
R31
Q3
R991
R992
C992
C993
E
C991
LF
C996
Q991
1 GND
2 LED PON
3 GND
4 KEY0
5 V+12
B
C995
115
BDP-05FD
CN3
C22
V+12
C17
C5
R1
C1
C2
C3
C61
E
VWG2613
A VWG
L1
R2
R42
20
C62
Q991
A
E
LF
8
7
R45
C23
Q4
C25
R59
15
C35
C33
R92
R94
10
C30
C28
C63
(VNP2106-A)
8-A)
C4
V+12
R91
C54
40
C53
35
45
75
5
30
50
70
1
R78
C
C24
R81
C48
R79
R93
R44
55
65
80
C32
1
5
C997
60
R90
R89
5
R57
CN991
Only
V+12
R100
R98
R97
R96
R95
R99
R101
C64
C27
Q
IC
PSWB ASSY
C
C59
C60
E
C
1
R102
C40
R62
25
C49
C34
21
20
VWG2612
VWG2625
VWG
R70
R69
40
1
6
5
C31
R80
B
60
R82
41 FLDC+
80
IC2
I
1:V+12
2:KEY0
3:GND
4:LED_PON
5:GND
61
8
7
6
5
SIDE B
A
C
(VNP2106-A)
D
CN991
F
C B
1
2
3
4
11.3 AUJB ASSY
SIDE A
SIDE A
A
IC
Q
D
A
AUJB ASSY
CN8901
R240
A
R25
R12
R16
R17
R43
C40
C42
C26
C49
C6 8
R23
R10
IC4
C46
IC6
C22
R20 C24
R47
R46
R44
R48
R52
E
E
C123
C137
C145
R6
R21
R3
R34
R33
R32
R31
A
C217
R57
R143
R142
R141
R140
C142
IC14
R153
R152
R150
R154
R2
E
R147
R146 C138
R145
R144
C124
C146
R8
IC2
C12
C16
E
R158
R24
R11
C6 7
R67
C65
R64
R65
R54
R55
C6 6
C163
C164
R173
R172
R162
R163
R160
C161
R170
R171
R161
C162
C144
IC15
R156
R155
R151
R157
C165
C167
C168
R174
R175
R177
R164 R176
R166 R167
E
C148
R159
C158
E
C152
R169
Q12 R187
Q14
R223 R201
C41
C72
C50
C27
C150
C221
C38
C39
R58
C220
PC
R41
R50
R49
C61
R45
R51
C63
R38
R37
R36
R35
R61
C37
C33
C44
C29
C31
C47
C219
E
C52
E
C62
C54
R236
LF
B
C94
R237
C56
R63
Q2
R85
Q4
R121 R99
R53
C70
C69
R68
R69
R70
R60
R71
C64
R59
C71
C135
C136
R149
C143
R165
C182 C176
C1 7 1
C78
C88
C76
C80
C86
R77
R106R95
C75
R88
1
C93
C166
C184 C174
C1 7 2
C183
R191
IC19
IC18
C181
C87
R89
IC11
IC10
C85
5
R7
IC1
C11
C15
C19
L3
R9 R14
IC3
C13 R13
C17
L2
R19
R18
C229
C228
C227
C226
C225
R188
C204
R190
C108
R102
R94
R76
C103
R110
R114 C99
C157
C96
1
R78
R107 R96
1
R66
R56
C84
C74
C79
C82
C73
C180 C1 7 3
C170
IC16
C177
C178 C175
C169
C185
C191
C189
C95
C115
IC13
C107
R119
R118
5
C100
C112
AUJB
VWG2615
VWG
R82
R83
R197
C104 R111
5
C116
C159
C190
R103 R97
R79
E
Q2
Q4
IC8
C81
C179
R189
IC17
C202
R202
IC20
C197 C201
IC21
C203
C199
1
R208 R183
R115
IC10
R196
R182
R204
5
R212
R216 C195
IC11
IC7
IC13
R87
IC9
C106
R100
R86
C89
C187
C205
R225
R226
C207
R221
R230
C208
JA4
R220
R229
C211
R132
R130
1
C111
R131
Q9
R138
KN3
C77
C83
C91
R123
C110
C117
R129
R128
Q7 R127 C120
R219
R218
C206
R137 Q8
C119
C214
C213
C215
1
1
E
Q10
E
Q10
Q12 Q9
Q14
C121
C122
R133
R198
C134
C130
C140
C126
C128
C48
IC7
C109
R116
IC12
C105
C118
R124
R117
1
1
5
C216
R228
R184
R209
C151
R168
Q11 R186
Q13 R200
R222
C160
15
E
Q18
Q17
C212
C192
20
R139
1
C200 R213
5
R234
IC18
C196
R217
R231
E
Q18
Q17
R199
R185
5
C149
C186
25
R224
R232
R235
IC15
IC21
R205
[[ G ]]
A30C5/C7
C147
C154
10
IC19
R206 R179
R193
R148
C141
5
D
E
Q16
Q15
E
Q16
Q15
1
C132
C133
1
R233
R192
R178
5
R210
R214 C193
R126
R227
R136
Q11
Q13
1
C153
15
Q7
C209
C155
20
IC16
E
R180
R207R194
C131
C129
C139
C125
C127
25
JA3
E
Q8
1
C198 R211
5
C210
C156
10
JA1
IC14
IC20
5
C194
R215
C188
R195
R181
5
IC17
C53
C90
R203
C55
R62
Q1
R84
Q3
R98
R120
1
E
R122
R134
C
R104R91R73
C51
C58
1
1
5
R108
R112 C97
R40
C45
15
Q5
R26
R239
R15
C35
C36
20
Q5
C57
25
C101
C59
10
1
R74
R90
R72
5
R105 R92
C2
C3
C4R22
1
C113
5
IC8
Q1
Q3
C114
15
JA2
C102 R109
5
1
C34
C32
C43
C28
C30
20
IC6
IC12 IC4
R113
R1
C60
25
Q6 E
5
C98
10
R125
5
Q6
R101 R93
R75
5
R135
R42
R39
C92
KN4
IC9
IC2
C10
D3
IC22
IC1
C6
D2
R30
1
1
IC22
D4
5
C25
C7
R238
1
C1
R4
C9
C14
1
D1
C223
5
R5
L1
C222
C224
1
C23
20
R27
C18
C8
10
L4
1
B
25
C20
PRINTED SIDE
C5
IC5
IC3
1
R28
R29
R81
IC5
15
27
5
C21
CN1
R80
1
1/2
A
CN1
(VNP2107-A)
F
D
116
BDP-05FD
1
2
3
4
5
6
7
8
SIDE B
SIDE B
A
CN1
B
C
D
E
LF
(VNP2107-A)
F
D
117
BDP-05FD
5
6
7
8
1
2
3
4
11.4 SYPS ASSY
SIDE A
BD/DVD/CD DRIVE
CN401
G
B
SYPS ASSY
A CN7002
A CN7001
CN202
CN201
SIDE A
CN203
A
C
D
CN101
AC INLET ASSY
E
F
G
G
118
BDP-05FD
1
2
3
4
5
6
7
8
SIDE B
SIDE B
G
A
SYPS ASSY
B
C
D
E
F
G
G
119
BDP-05FD
5
6
7
8
1
2
3
4
12. PCB PARTS LIST
NOTES:
Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47 k ohm (tolerance is shown by J = 5%,
and K = 10%).
-
A
560 Ω
47 kΩ
0.5 Ω
1Ω
→
→
→
→
56 × 101 →
561 ................................................................... RD1/4PU 5
473 ................................................................... RD1/4PU 4
47 × 103 →
R50 ................................................................................................. RN2H R 5
1R0 ................................................................................................. RS1P 1 R
6 1 J
7 3 J
0 K
0 K
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
5.62 kΩ →
-
B
562 × 101 →
5621 ................................................................. RN1/4PC 5 6 2 1 F
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board.
IC 301 (A, 91, 111) IC NJM2068V
Mark No. Description
Mark No. Description
Part No.
LIST OF ASSEMBLIES
1..SERVICE MAIN ASSY (BDP-05FD)
1..SERVICE MAIN ASSY (BDP-51FD)
2..MAIN ASSY (BDP2.0)(BDP-05FD)
2..MAIN ASSY (BDP2.0)(BDP-51FD)
2..ATAB ASSY (BDP2.0)
VXX3326
VXX3328
VWV2315
VWV2375
VWV2360
NSP
NSP
1..FLKB ASSY (BDP-05FD)
1..FLKB ASSY (BDP-51FD)
2..FLKY ASSY (BDP-05FD)
2..FLKY ASSY (BDP-51FD)
2..PSWB ASSY
VWM2463
VWM2481
VWG2612
VWG2625
VWG2613
NSP
NSP
1..AUJB ASSY (BDP-05FD)
1..AUJB ASSY (BDP-51FD)
VWG2615
VWG2632
1..CAPK ASSY (BDP-05FD only)
VWG2614
1..SYPS ASSY
VWR1415
1..DRIVE ASSY BDY-103
VXX3325
NSP
NSP
C
>
D
Mark No. Description
A
E
IC
IC
IC
IC
IC
MAIN ASSY (BDP2.0) (BDP-05FD)
1001
2101,2201,2301,2401
2151,2351,3151,5301
2601,3301
3101,3201
R8A34019BG
EDE5108AJBG-6E-E
S-1170B18UC-OTD
LP2996M
EDE5116AJBG-6E-E
3501
3551,4351
3801
4001
4002
VYW2414
TC7SH08FUS1
PDJ015A
PDC178A8
BD45282G
> IC 4101,7301,7311
F
IC
IC
> IC
> IC
4201
5001
5311
5321
IC 5401,8001
IC 6001
IC 6301
S-1170B33UC-OTS
BU4809F
SII9134CTU
S-L2980A33MC-C6S
NJM2370U1-05
ICS571MLF
NJM2566AV
ADV7340BSTZ
120
> IC 7421
> IC 7501
IC 8011
IC 8031
IC 8101
S-1170B50UC-OUJ
S-L2980A50MC-C7J
TC7WH74FU
TC74VHC157FTS1
LMH6658MMX
Q
Q
Q
Q
Q
4001,4004,5232,6111
4002,4003,5202
5201
5211,5221
5231
2SA1576A
DTC124EUA
UMB1N
UM6K1N
HN1C03FU
Q
Q
Q
>Q
Q
6121,6131,6141,6151
6161,8181
8171
8801
8812
2SA1576A
2SA1576A
2SC4081
2SC5712
UMD2N
1SS355
RB501V-40
UDZS7R5(B)
MISCELLANEOUS
SEMICONDUCTORS
IC
IC
> IC
> IC
IC
TPS74901KTW
S-1170B18UC-OTD
D 4001,4002
D 4351,6001-6004
D 8801
Part No.
Part No.
> IC 7101
> IC 7201,7331
L
L
L
L
L
3801,3802,8901 INDUCTOR
4402-4406,4412-4417 INDUCTOR
4407,4408,4410,4411 INDUCTOR
4421,5051,5052,5061 INDUCTOR
5062,5105,6001 INDUCTOR
CTF1384
CTF1306
CTF1394
CTF1394
CTF1394
L
L
L
F
F
5106-5109 INDUCTOR
5401 INDUCTOR
6301-6304 INDUCTOR
1401,1431,2101,2301 EMI FILTER
3101,3201,3501,3701 EMI FILTER
CTF1306
CTF1357
CTF1394
DTL1106
DTL1106
F
F
F
JA
JA
3801 EMI FILTER
4001,5001-5003,8001 EMI FILTER
5007-5010 EMI FILTER
3701 SDCARD SLOTCONNECTOR
4351 JACK
DTL1106
VTL1171
ATF1209
DKP3748
RKN1004
JA
JA
JA
JA
X
5001
6001
6002
8001
3801
AKP7220
AKB7159
VKB1198
VKX1023
VSS1226
HDMI CONNECTOR
COMB.JACK(S+1P)
3P PIN JACK
JACK BOARD
CRYSTAL RESONATOR
BDP-05FD
1
2
3
4
5
Mark No. Description
X
CN
CN
CN
CN
4001
1501
1601
4401
7001
CERAMIC RESONATOR (12 MHz)
CONNECTOR
11P CONNECTOR
30P CONNECTOR
CONNECTOR
CN 7002 CONNECTOR
CN 8801 CONNECTOR
CN 8901 27P CONNECTOR
0
SD MEMORY CARD
6
Part No.
7
Mark No. Description
VSS1216
VKN2050
RKN1052
VKN1620
AKM1284
AKM1282
AKM1273
VKN1617
VWX1233
RESISTORS
R
R
R
R
R
1001-1004,2111,2112
1105,1117,1119
1111,1115,1623,3803
1122-1124,1176,1177
1145,1146,1552-1555
RS1/16SS82R0F
RAB4CQ220J
RS1/16S220J
RAB4CQ220J
RAB4CQ223J
R
R
R
R
R
1166,1167
1171
1172
1182,1184-1194,1211
1183
RS1/16SS1500F
RS1/16SS8200F
RS1/16SS1000F
RAB4CQ470J
RS1/16S100J
R
R
R
R
R
1195,3814,7501,8001
1201,1251,2154,2354
1213,5026
1214,1238,1252,1253
1302,1327,1328
RS1/16S470J
RS1/16S0R0J
RAB4CQ470J
RAB4CQ103J
RAB4CQ330J
R
R
R
R
R
1332,1335
1401,1402,1441-1445
1502-1505,1513
1591,6211,6214,7321
1601,1602,1605,1606
RAB4CQ472J
RS1/10S0R0J
RAB4CQ330J
RS1/10S0R0J
RS1/16S221J
R
R
R
R
R
1610,1611,1622,1651
1652,4351,4353,6326
2211,2212,2311,2312
2411,2412,3111,3112
2615-2619,3303-3308
RS1/16S221J
RS1/16S221J
RS1/16SS82R0F
RS1/16SS82R0F
RAB4CQ220J
R
R
R
R
R
2637-2641,3341-3346
3154,3513,3833,3843
3211,3212
3591-3594,3791,3792
3804,3817,3819,5022
RAB4CQ750J
RS1/16S0R0J
RS1/16SS82R0F
RAB4CQ103J
RS1/16S220J
R
R
R
R
R
3805,3806,4015,4016
3815,8002
4017,4019,5234,5235
4024,8813
4061,4317,4602,5015
RS1/16S103J
RS1/16S330J
RS1/16S472J
RS1/16S471J
RS1/16S0R0J
R
R
R
R
R
4063
4071,7332
4072,4316
4241,4355,6308,7102
4352,7301,7311,7421
RAB4CQ223J
RS1/16S223J
RS1/16S104J
RS1/16S103J
RS1/16S101J
R
R
R
R
R
4354
4583,4585,4591,4593
5019,5030,5031,5043
5023,5039,5049-5052
5033,5034,5057,5211
RS1/16S224J
RAB4CQ103J
RAB4CQ103J
RS1/16S220J
RS1/16S0R0J
R
R
R
R
R
5035
5036
5041,5044,5045,6301
5231
5232,8015
RS1/16S180J
RS1/16S6800F
RAB4CQ220J
RS1/16S473J
RS1/16S102J
8
Part No.
R
R
R
R
R
5233,5237
5236
5238
5321,5401,5402,6004
5405
RS1/16S272J
RS1/16S562J
RS1/16S472J
RS1/16S0R0J
RS1/16S22R0F
R
R
R
R
R
5406
6001,6007,7101,8181
6002,6008,7205
6006,6010-6012,6321
6111,6121,6131
RS1/16S62R0D
RS1/16S332J
RS1/16S682J
RS1/16S0R0J
RS1/16S75R0F
R
R
R
R
R
6141,6151,6161
6201,6204
6202,6203,6205,6206
6212,6213
6215,6216
RS1/16S3000F
RS1/10S75R0F
RS1/10S68R0F
RS1/10S4R7J
RS1/10S5R6J
R
R
R
R
R
6302,6317
6319,6320
6322,6324
6323,6325,6328
6327
RAB4CQ220J
RS1/16S392J
RS1/16S151J
RS1/16S200J
RS1/16S3901F
R
R
R
R
R
6329
6336,7204,8051,8107
6345
7103
7104
RS1/16S1001F
RS1/16S0R0J
RAB4CQ0R0J
RS1/16S1201D
RS1/16S2701D
R
R
R
R
R
7105
7206,8111
7333
7601,7603,7651,7653
8004-8006,8031,8035
RS1/16S3300D
RS1/16S103J
RS1/16S333J
RS1/10S0R0J
RS1/16S220J
R
R
R
R
R
8036,8048
8101
8102
8103
8104
RS1/16S220J
RN1/16SE2201D
RS1/16S101J
RN1/16SE6800D
RS1/16S331J
R
R
R
R
R
8105
8106
8108,8121,8131,8132
8112,8816,8921
8171,8182
RS1/16S152J
RN1/10SC75R0D
RS1/16S0R0J
RS1/10S0R0J
RS1/16S122J
R 8172
R 8206,8901-8903,8924
R 8811,8821,8905-8910
R 8815
Other Resistors
6
B
C
D
RS1/16S222J
RS1/16S470J
RS1/16S0R0J
RS1/16S561J
RS1/16SS###J
E
CAPACITORS
C
C
C
C
C
1001,1003,1005,1006
1002,1007,1010,1011
1004,1009,1016,1019
1008,1012,1013,1015
1014,1018,1021,1029
VCG1063
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
C
C
C
C
C
1017,1020,1022,1024
1023,1026,1031,1041
1025,1027,1028,1030
1032,1035-1037,1039
1033,1034,1038,1040
VCG1063
CKSRYF105Z10
VCG1063
CKSSYF104Z16
VCG1063
C 1042,1044,1046,1048
C 1043,1045,1049,1050
C 1047,1062,1066,1068
VCG1063
CKSSYF104Z16
CKSRYF105Z10
F
121
BDP-05FD
5
A
7
8
1
Mark No. Description
A
B
C
D
E
F
2
Part No.
C 1051-1053,1055-1058
C 1054,1064,1070,1082
VCG1063
CKSSYF104Z16
C
C
C
C
C
1061,1063,1065,1067
1069,1071,1081,1084
1072,1083,1301,1403
1085,1087,1089,1090
1086,1088,1091,1161
VCG1063
VCG1063
CKSRYF105Z10
CKSSYF104Z16
VCG1063
C
C
C
C
C
1201-1203
1204,3712,8927
1209,1211,3823,3824
1401,1441,2202,2302
1404,3505,4352,4355
CCSSCH180J50
CCSSCH100D50
CCSRCH180J50
VCH1234
CKSRYF104Z50
C
C
C
C
C
1405,1445,1448,2102
1406,1407,1409,1435
1408,3507,5011,5042
1431,4002,7204
1433,1443,1591,1601
CEVLW221M4
CCG1171
VCG1057
VCH1269
CKSRYF105Z10
C
C
C
C
C
1434,1444,1592,3506
1446,1447,1449,2151
1501,1603,1604
1502
1607-1610,1653,1654
CCSRCH102J50
CCG1171
CCSRCH101J50
CCSRCH470J50
CCSRCH101J50
C
C
C
C
C
2103,2107,2111,2112
2104,2109,2114,2117
2105,2106,2108,2110
2113,2115,2205,2206
2116,2203,2207,2211
CKSRYF105Z10
CKSSYF104Z16
VCG1063
VCG1063
CKSRYF105Z10
C
C
C
C
C
2118,2204,2209,2214
2152,2351,2352,2602
2153,2353,3153,4018
2208,2210,2213,2215
2212,2216,2303,2307
CKSSYF104Z16
CCG1171
CCSRCH101J50
VCG1063
CKSRYF105Z10
C
C
C
C
C
2217,2218,2304,2309
2305,2306,2308,2310
2311,2312,2316,2403
2313,2315,2405,2406
2314,2317,2318,2404
CKSSYF104Z16
VCG1063
CKSRYF105Z10
VCG1063
CKSSYF104Z16
C
C
C
C
C
2402,2601,2604,3301
2407,2411,2412,2416
2408,2410,2413,2415
2409,2414,2417,2418
2603,2607,3104,3109
CEVLW221M4
CKSRYF105Z10
VCG1063
CKSSYF104Z16
CKSSYF104Z16
C
C
C
C
C
2605,3305,5009,5323
2606,3103,3107,3114
2608,3105,3106,3108
3102,3202,6001,6307
3110,3111,3113,3116
CEVLW101M10
CKSRYF105Z10
VCG1063
CCH1688
VCG1063
C
C
C
C
C
3112,3117,3120,3123
3115,3122,3203,3207
3118,3119,3121,3205
3124,3204,3209,3212
3151,3152,3302,3502
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
CCG1171
C
C
C
C
C
3206,3208,3210,3211
3213,3216,3218,3219
3214,3215,3222,3306
3217,3220,3223,3224
3221,3308,3503,4020
VCG1063
VCG1063
CKSRYF105Z10
CKSSYF104Z16
VCG1063
C 3303,3307,4011,4021
C 3304,3702,5002,5006
CKSSYF104Z16
CEVLW221M4
122
3
Mark No. Description
4
Part No.
C 3501
C 3504,3701,3803,3861
C 3703,3710,3711
CEVW221M4
CKSRYF105Z10
CCSRCH102J50
C
C
C
C
C
3802,5010,5407,7103
3804,3862,4102,5047
3805-3808,4003,4004
3821,3822
4012,4013,4402,4406
VCH1234
CCG1171
CCSRCH102J50
CCSSCH120J50
CCSRCH102J50
C
C
C
C
C
4016
4017,4019
4022,4026,5014,5023
4071,4601,5003,5007
4101,5321,5322,7422
VCG1061
CKSSYF103Z50
VCG1063
CKSRYF105Z10
CKSQYB225K10
C
C
C
C
C
4201,4202,4222,4223
4221,4356,5303,5313
4351
4401,4407,4409,4411
4403-4405,8102
CKSSYF104Z16
CCSRCH101J50
CCSRCH681J50
CKSRYF104Z50
CCSRCH220J50
C
C
C
C
C
4408,7503
4410,4413,4416,5004
4412,6202,6322
4414,5324,7105,7107
4415
CEVW101M16
CCSRCH102J50
CKSRYF104Z50
CKSRYB105K16
CEVW470M35
C
C
C
C
C
5008,5053,5063,5066
5013,5021,5022,5045
5041,5043,5056,5057
5044,5067,5805-5807
5046,5048-5051,5401
CCSRCH102J50
CKSSYF104Z16
VCG1063
VCG1057
CKSSYF104Z16
C
C
C
C
C
5052,5062,5065,5301
5054,6304,7304
5302,5311,5312
5402
5403,6002,6313,6314
CCG1171
CEVLW221M4
CCG1171
CKSRYF105Z10
VCG1063
C
C
C
C
C
5404,7005,7101,8003
5405
5409,5414,8926
5802-5804,5811,6303
6003,6004,6006,6007
CCSRCH102J50
CCSRCH5R0C50
CCSSCH101J50
CKSSYF104Z16
CCG1205
C
C
C
C
C
6011-6017,6302,6305
6111,6121,6131,6141
6151,6161,6327,8006
6201,6203-6206
6306,6309,6312,6325
CCG1171
VCG1057
VCG1057
CEVW102M6R3
CKSSYF104Z16
C
C
C
C
C
6308,6311,7102,7104
6315,6317
6316,6318
6319,6321,8005,8011
6323,6324
CCG1171
CKSRYB123K50
CKSRYB154K10
VCG1063
CKSRYB222K50
C
C
C
C
C
6328,6329
7001-7004,7006,7007
7008,7201,7301,7421
7106,7313
7202,7203,7302,7303
CCSRCH330J50
CKSRYF104Z50
CEVLW101M10
CCH1688
CCG1171
C
C
C
C
C
7205,7334
7305,7314,7425
7311,7312,7322,7331
7332,7423,7502
7333,8002
CKSRYB105K16
CCSRCH101J50
CCG1171
CCG1171
VCH1234
C 7501
CKSQYB225K10
BDP-05FD
1
2
3
4
5
Mark No. Description
6
Part No.
C
C
C
C
7601,7603,7651,7653
7602,7652,8801,8802
8004,8032,8175,8185
8012
CKSRYF104Z50
CEVLW470M16
CCSRCH102J50
VCG1057
C
C
C
C
C
8031
8101
8104,8901,8903,8905
8111
8115,8171-8173
CKSSYF104Z16
CCSRCH820J50
CKSRYB104K50
VCH1241
CKSRYF104Z50
C
C
C
C
C
8117,8922-8924,8932
8174,8184
8181-8183,8803-8805
8906,8908
8907
VCG1063
VCH1267
CKSRYF104Z50
CCSQCH101J50
CKSRYB104K50
C 8921
C 8933
7
Mark No. Description
D 8801
ATAB ASSY (BDP2.0) (BDP-05FD)
MISCELLANEOUS
VKN1818
VKN1816
A MAIN ASSY (BDP2.0) (BDP-51FD)
SEMICONDUCTORS
IC
IC
> IC
> IC
IC
IC
IC
IC
IC
IC
1001
2101,2201,2301,2401
2151,2351,3151,5301
2601,3301
3101,3201
R8A34019BG
EDE5108AJBG-6E-E
S-1170B18UC-OTD
LP2996M
EDE5116AJBG-6E-E
3501
3551,4351
3801
4001
4002
VYW2414
TC7SH08FUS1
PDJ015A
PDC178A8
BD45282G
> IC 4101,7301,7311
IC
IC
> IC
> IC
4201
5001
5311
5321
S-1170B33UC-OTS
BU4809F
SII9134CTU
S-L2980A33MC-C6S
NJM2370U1-05
IC
IC
> IC
> IC
> IC
5401,8001
6001
7101
7201
7421
ICS571MLF
NJM2566AV
TPS74901KTW
S-1170B18UC-OTD
S-1170B50UC-OUJ
> IC 7501
IC
IC
IC
Q
8011
8031
8101
4001,4004,5232
S-L2980A50MC-C7J
TC7WH74FU
TC74VHC157FTS1
LMH6658MMX
2SA1576A
Q
Q
Q
Q
Q
4002,4003,5202
5201
5211,5221
5231
6501-6505,8181
DTC124EUA
UMB1N
UM6K1N
HN1C03FU
2SA1576A
Q 8171
> Q 8801
Q 8812
D 4001,4002
D 4351,6001-6004
Part No.
UDZS7R5(B)
A
MISCELLANEOUS
CEVLW101M10
VCG1063
CN 9001 40P CONNECTOR
CN 9003 40P ATA CONECTOR
8
L
L
L
L
L
3801,3802,8901 INDUCTOR
4402-4406,4412-4417 INDUCTOR
4407,4408,4410,4411 INDUCTOR
4421,5051,5052,5061 INDUCTOR
5062,5105,6001,6301 INDUCTOR
CTF1384
CTF1306
CTF1394
CTF1394
CTF1394
L
L
F
F
F
5106-5109 INDUCTOR
5401 INDUCTOR
1401,1421,1431,2101 EMI FILTER
2301,3101,3201,3501 EMI FILTER
3701,3801 EMI FILTER
CTF1306
CTF1357
DTL1106
DTL1106
DTL1106
F
F
JA
JA
JA
4001,5001-5003,8001 EMI FILTER
5007-5010 EMI FILTER
3701 SDCARD SLOTCONNECTOR
4351 JACK
5001 HDMI CONNECTOR
VTL1171
ATF1209
DKP3748
RKN1004
AKP7220
JA
JA
JA
X
X
6001
6002
8001
3801
4001
COMB.JACK(S+1P)
JACK
JACK BOARD
CRYSTAL RESONATOR
CERAMIC RESONATOR (12 MHz)
AKB7146
VKB1165
VKX1024
VSS1226
VSS1216
CN
CN
CN
CN
CN
1501
1601
4401
7001
7002
CONNECTOR
11P CONNECTOR
30P CONNECTOR
CONNECTOR
CONNECTOR
VKN2050
RKN1052
VKN1620
AKM1284
AKM1282
CN 8801 CONNECTOR
CN 8901 27P CONNECTOR
0
SD MEMORY CARD
RESISTORS
2SC4081
2SC5712
UMD2N
1SS355
RB501V-40
6
C
AKM1273
VKN1617
VWX1233
R
R
R
R
R
1001-1004,2111,2112
1105,1117,1119
1111,1115,1183,1623
1122-1124,1176,1177
1145,1146,1552-1555
RS1/16SS82R0F
RAB4CQ220J
RS1/16S220J
RAB4CQ220J
RAB4CQ223J
R
R
R
R
R
1166,1167
1171
1172
1182,1184-1189,1193
1194,1211,1213,5026
RS1/16SS1500F
RS1/16SS8200F
RS1/16SS1000F
RAB4CQ470J
RAB4CQ470J
R
R
R
R
R
1201,1251,2154,2354
1214,1238,1252,1253
1302,1327,1328
1332,1335
1401,1441-1445,1591
RS1/16S0R0J
RAB4CQ103J
RAB4CQ330J
RAB4CQ472J
RS1/10S0R0J
R
R
R
R
R
1502-1505,1513
1601,1602,1605,1606
1610,1611,1622,1651
1652,4351,4353
2211,2212,2311,2312
RAB4CQ330J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16SS82R0F
R
R
R
R
R
2411,2412,3111,3112
2615-2619,3303-3308
2637-2641,3341-3346
3154,3513,3833,3843
3211,3212
RS1/16SS82R0F
RAB4CQ220J
RAB4CQ750J
RS1/16S0R0J
RS1/16SS82R0F
R 3591-3594,3791,3792
R 3803,3804,3817,3819
D
E
F
RAB4CQ103J
RS1/16S220J
123
BDP-05FD
5
B
7
8
1
Mark No. Description
2
Part No.
R 3805,3806,4015,4016
R 3814,7501,8001,8206
R 3815,8002
RS1/16S103J
RS1/16S470J
RS1/16S330J
R
R
R
R
R
4017,4019,5234,5235
4024,8813
4061,4317,4602,5015
4063
4071
RS1/16S472J
RS1/16S471J
RS1/16S0R0J
RAB4CQ223J
RS1/16S223J
R
R
R
R
R
4072,4316
4241,4355,7102,7206
4352,7301,7311,7421
4354
4583,4585,4591,4593
RS1/16S104J
RS1/16S103J
RS1/16S101J
RS1/16S224J
RAB4CQ103J
R
R
R
R
R
5019,5030,5031,5043
5022,5023,5039
5033,5034,5057,5211
5035
5036
RAB4CQ103J
RS1/16S220J
RS1/16S0R0J
RS1/16S180J
RS1/16S6800F
R
R
R
R
R
5041,5044,5045
5049-5052,8004-8006
5231
5232,8015
5233,5237
RAB4CQ220J
RS1/16S220J
RS1/16S473J
RS1/16S102J
RS1/16S272J
R
R
R
R
R
5236
5238
5321,5401,6003,6006
5405
5406
RS1/16S562J
RS1/16S472J
RS1/16S0R0J
RS1/16S22R0F
RS1/16S62R0D
R
R
R
R
R
6001,6007,7101,8181
6002,6008,7205
6010-6012,7204,8051
6201-6206
6211-6216,7321,7601
RS1/16S332J
RS1/16S682J
RS1/16S0R0J
RS1/10S75R0F
RS1/10S0R0J
R
R
R
R
R
6319,6320
6501,6505,6509,6513
6517
7103
7104
RS1/16S392J
RS1/16S1000F
RS1/16S1000F
RS1/16S1201D
RS1/16S2701D
R
R
R
R
R
7105
7603,7651,7653,8112
8031,8035,8036,8048
8101
8102
RS1/16S3300D
RS1/10S0R0J
RS1/16S220J
RN1/16SE2201D
RS1/16S101J
R
R
R
R
R
8103
8104
8105
8106
8107,8108,8121,8131
RN1/16SE6800D
RS1/16S331J
RS1/16S152J
RN1/10SC75R0D
RS1/16S0R0J
R
R
R
R
R
8111
8132,8811,8821
8171,8182
8172
8815
RS1/16S103J
RS1/16S0R0J
RS1/16S122J
RS1/16S222J
RS1/16S561J
3
Mark No. Description
A
B
C
D
E
F
R 8816,8921
R 8901-8903,8924
R 8905-8910
Other Resistors
RS1/10S0R0J
RS1/16S470J
RS1/16S0R0J
RS1/16SS###J
CAPACITORS
C 1001,1003,1005,1006
4
Part No.
C
C
C
C
1002,1007,1010,1011
1004,1009,1016,1019
1008,1012,1013,1015
1014,1018,1021,1029
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
C
C
C
C
C
1017,1020,1022,1024
1023,1026,1031,1041
1025,1027,1028,1030
1032,1035-1037,1039
1033,1034,1038,1040
VCG1063
CKSRYF105Z10
VCG1063
CKSSYF104Z16
VCG1063
C
C
C
C
C
1042,1044,1046,1048
1043,1045,1049,1050
1047,1062,1066,1068
1051-1053,1055-1058
1054,1064,1070,1082
VCG1063
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
C
C
C
C
C
1061,1063,1065,1067
1069,1071,1081,1084
1072,1083,1301,1403
1085,1087,1089,1090
1086,1088,1091,1161
VCG1063
VCG1063
CKSRYF105Z10
CKSSYF104Z16
VCG1063
C
C
C
C
C
1201-1203
1204,3712,8927
1209,1211,3823,3824
1401,1441,2202,2302
1404,3505,4352,4355
CCSSCH180J50
CCSSCH100D50
CCSRCH180J50
VCH1234
CKSRYF104Z50
C
C
C
C
C
1405,1421,1445,1448
1406,1407,1409,1424
1408,3507,5011,5042
1422,1433,1443,1591
1423,1434,1444,1592
CEVLW221M4
CCG1171
VCG1057
CKSRYF105Z10
CCSRCH102J50
C
C
C
C
C
1431,4002,7204
1435,1446,1447,1449
1501,1603,1604
1502
1601,2103,2107,2111
VCH1269
CCG1171
CCSRCH101J50
CCSRCH470J50
CKSRYF105Z10
C
C
C
C
C
1607-1610,1653,1654
2102,2402,2601,2604
2104,2109,2114,2117
2105,2106,2108,2110
2112,2116,2203,2207
CCSRCH101J50
CEVLW221M4
CKSSYF104Z16
VCG1063
CKSRYF105Z10
C
C
C
C
C
2113,2115,2205,2206
2118,2204,2209,2214
2151,2152,2351,2352
2153,2353,3153,4018
2208,2210,2213,2215
VCG1063
CKSSYF104Z16
CCG1171
CCSRCH101J50
VCG1063
C
C
C
C
C
2211,2212,2216,2303
2217,2218,2304,2309
2305,2306,2308,2310
2307,2311,2312,2316
2313,2315,2405,2406
CKSRYF105Z10
CKSSYF104Z16
VCG1063
CKSRYF105Z10
VCG1063
C
C
C
C
C
2314,2317,2318,2404
2403,2407,2411,2412
2408,2410,2413,2415
2409,2414,2417,2418
2416,2606,3103,3107
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
CKSRYF105Z10
C
C
C
C
C
2602,3151,3152,3302
2603,2607,3104,3109
2605,3305,5009,5323
2608,3105,3106,3108
3102,3202,6001,7106
CCG1171
CKSSYF104Z16
CEVLW101M10
VCG1063
CCH1688
VCG1063
124
BDP-05FD
1
2
3
4
5
Mark No. Description
6
Part No.
7
Mark No. Description
8
Part No.
C
C
C
C
C
3110,3111,3113,3116
3112,3117,3120,3123
3114,3115,3122,3203
3118,3119,3121,3205
3124,3204,3209,3212
VCG1063
CKSSYF104Z16
CKSRYF105Z10
VCG1063
CKSSYF104Z16
C
C
C
C
C
3206,3208,3210,3211
3207,3214,3215,3222
3213,3216,3218,3219
3217,3220,3223,3224
3221,3308,3503,4020
VCG1063
CKSRYF105Z10
VCG1063
CKSSYF104Z16
VCG1063
C
C
C
C
C
3301,3304,3702,5002
3303,3307,4011,4021
3306,3504,3701,3803
3501
3502,3804,3862,4102
CEVLW221M4
CKSSYF104Z16
CKSRYF105Z10
CEVW221M4
CCG1171
C
C
C
C
C
3506,3703,3710,3711
3802,5010,5407,7103
3805-3808,4003,4004
3821,3822
3861,4071,4601,5003
CCSRCH102J50
VCH1234
CCSRCH102J50
CCSSCH120J50
CKSRYF105Z10
C
C
C
C
C
4012,4013,4402,4406
4016
4017,4019
4022,4026,5014,5023
4101,5321,5322,7422
CCSRCH102J50
VCG1061
CKSSYF103Z50
VCG1063
CKSQYB225K10
C
C
C
C
C
4201,4202,4222,4223
4221,4356,5303,5313
4351
4401,4407,4409,4411
4403-4405,8102
CKSSYF104Z16
CCSRCH101J50
CCSRCH681J50
CKSRYF104Z50
CCSRCH220J50
C
C
C
C
C
4408,7503
4410,4413,4416,5004
4412,6202,7001-7004
4414,5324,7105,7107
4415
CEVW101M16
CCSRCH102J50
CKSRYF104Z50
CKSRYB105K16
CEVW470M35
C
C
C
C
C
5006,5054,7304
5007,5402
5008,5053,5063,5066
5013,5021,5022,5045
5041,5043,5056,5057
CEVLW221M4
CKSRYF105Z10
CCSRCH102J50
CKSSYF104Z16
VCG1063
C
C
C
C
C
5044,5067,5805-5807
5046,5048-5051,5401
5047,5052,5062,5065
5301,5302,5311,5312
5403,6002,8005,8011
VCG1057
CKSSYF104Z16
CCG1171
CCG1171
VCG1063
C
C
C
C
C
5404,7005,7101,8003
5405
5409,5414,8926
5802-5804,5811,6018
6003,6004,6006,6007
CCSRCH102J50
CCSRCH5R0C50
CCSSCH101J50
CKSSYF104Z16
CCG1205
R
R
R
R
R
6,73,107
8,71
21,72
31,35,42,67
37
CTF1394
RS1/10S123J
RS1/10S822J
RS1/10S222J
RS1/4SA0R0J
C
C
C
C
C
6011-6015,6017,7102
6201,6203-6206
6501-6505,8006,8012
7006,7007,7601,7603
7008,7201,7301,7421
CCG1171
CEVW102M6R3
VCG1057
CKSRYF104Z50
CEVLW101M10
R
R
R
R
R
52,53,74-77
55,56,62,63
68
81-84,89-94
95,96,100,101
RS1/4SA561J
RS1/10S152J
RS1/10S222J
RS1/4SA561J
RS1/4SA222J
C
C
C
C
C
7104,7202,7203,7302
7205
7303,7311,7312,7423
7305,7314,7425
7313
CCG1171
CKSRYB105K16
CCG1171
CCSRCH101J50
CCH1688
Other Resistors
C
C
C
C
C
7501
7502
7602,7652,8801,8802
7651,7653,8115
8002
CKSQYB225K10
CCG1171
CEVLW470M16
CKSRYF104Z50
VCH1234
C
C
C
C
C
8004,8032,8175,8185
8031
8101
8104,8901,8903,8905
8111
CCSRCH102J50
CKSSYF104Z16
CCSRCH820J50
CKSRYB104K50
VCH1241
C
C
C
C
C
8117,8922-8924,8932
8171-8173,8181-8183
8174,8184
8803-8805
8906,8908
VCG1063
CKSRYF104Z50
VCH1267
CKSRYF104Z50
CCSQCH101J50
C 8907
C 8921
C 8933
6
B
CKSRYB104K50
CEVLW101M10
VCG1063
ATAB ASSY (BDP2.0) (BDP-51FD)
MISCELLANEOUS
CN 9001 40P CONNECTOR
CN 9003 40P ATA CONECTOR
VKN1818
VKN1816
C
B FLKY ASSY (BDP-05FD)
SEMICONDUCTORS
IC
IC
>Q
Q
D
D
D
D
D
1
2
1,2
3-9
1
RPM7140-H4
PDC182A
2SA2060
DTC124EUA
UDZS2R0(B)
2
3,4,9
5,7
6,8
UDZS3R3(B)
SLR-343VC(NPQ)
SLR343BC4T(JKLM)
SLR343WBCT(MNPQ)
D
MISCELLANEOUS
KN
V
S
CN
CN
1
1
5
1
2,3
FL HOLDER (FE)
FLUORESCENT TUBE
SWITCH
30P CONNECTOR
5P CONNECTOR
VNF1142
VAW1094
VSG1024
VKN1290
VKN1236
RESISTORS
E
RS1/16S###J
F
CAPACITORS
C 2,12,31,67
C 3,8,9,11
CKSRYB105K16
CKSRYB104K50
125
BDP-05FD
5
A
7
8
1
Mark No. Description
2
3
Part No.
C 6
C 7,13,16,37
C 10,26
CEAT101M16
CEAL100M50
CEAL101M16
C
C
C
C
C
14,15,21,24
17,23,33,34
18
28
29,35,38,41
CKSRYB104K50
CKSRYB102K50
CEJQNP220M25
CKSYB105K16
CKSRYB104K50
C
C
C
C
C
30,47
44,50-52,54
45,53
55,66
59-65
CKSYB104K25
CKSRYB104K50
CKSRYB102K50
CKSRYB104K50
CCSRCH101J50
Mark No. Description
SEMICONDUCTORS
C 68
C 69,70
Q 991
D 991
S 991 SWITCH
CN 991 5P CONNECTOR
All Resistors
C
C
C
C
1
1
1-7
1
3
IC 1-3
VNF1142
VAW1094
VSG1024
VKN1290
VKN1236
R
R
R
R
R
6,73,107
8,71
21,72
31,35,42,67
37
CTF1394
RS1/10S123J
RS1/10S822J
RS1/10S222J
RS1/4SA0R0J
R 52,53,74-77
R 68
R 81-84,89-94
R 95,96,100,101
Other Resistors
RS1/4SA561J
RS1/10S222J
RS1/4SA561J
RS1/4SA222J
RS1/16S###J
F
C
C
C
C
C
2,12,31
3,8,9,11
6
7,13,16,37
10,26
CKSRYB105K16
CKSRYB104K50
CEAT101M16
CEAL100M50
CEAL101M16
C
C
C
C
C
14,15,21,24
17,23,33,34
18
28
30,47
CKSRYB104K50
CKSRYB102K50
CEJQNP220M25
CKSYB105K16
CKSYB104K25
C
C
C
C
35,38,50-52
45,53
54,55
59,60,62,65
CKSRYB104K50
CKSRYB102K50
CKSRYB104K50
CCSRCH101J50
126
2SA1576A
2SD2114K
1SS355
L
JA
JA
JA
KN
1-4
1,2
3
4
3,4
CN 1
CHIP BEADS
JACK
JACK
JACK
SCREW PLATE
DTF1070
VKB1160
VKB1129
VKB1138
VNE1948
27P CONNECTOR
VKN1617
RESISTORS
CAPACITORS
E
Q 3,4,13,14
Q 5-10,15-18
D 3,4
MISCELLANEOUS
RESISTORS
D
IC 6,7,14,15
IC 8-13,16-21
Q 1,2,11,12
TC7SHU04FUS1
NJM78M05FA
WM8740SEDS
NJM5532MD
2SC4081
> IC 5
UDZS3R3(B)
SLR-343VC(NPQ)
SLR343BC4T(JKLM)
FL HOLDER (FE)
FLUORESCENT TUBE
SWITCH
30P CONNECTOR
5P CONNECTOR
CCSRCH101J50
CKSRYB104K50
CKSRYB105K16
CEJQ100M25
SEMICONDUCTORS
MISCELLANEOUS
KN
V
S
CN
CN
991
992,995
993
994
D AUJB ASSY (BDP-05FD)
RPM7140-H4
PDC182A
2SA2060
DTC124EUA
UDZS2R0(B)
D 2
D 3,4,9
D 10
RS1/10S###J
CAPACITORS
CKSRYB103K50
CKSQYB106K6R3
1
2
1,2
3,4,6,9
1
VSG1024
VKN1236
RESISTORS
SEMICONDUCTORS
IC
IC
>Q
Q
D
DTC124EUA
SLR343BC4T(JKLM)
MISCELLANEOUS
B FLKY ASSY (BDP-51FD)
C
Part No.
C PSWB ASSY
A
B
4
R
R
R
R
R
1,2,23-25
3
4,5,10-12
15,28,29
54-61,160-167
RS1/16S470J
RS1/16S101J
RS1/10S0R0J
RS1/16S0R0J
RS1/16S1002D
R
R
R
R
R
62,63,168,169
64-79,170-185
80-83
84,85,186,187
86-89,188-191
RS1/16S472J
RS1/16S4300D
RS1/16S0R0J
RS1/16S332J
RS1/16S6800D
R 90-97,192-199
R 98,99,200,201
R 100-107,202-209
R 108-115,210-217
Other Resistors
RS1/16S1500D
RS1/16S103J
RN1/16SE1301D
RN1/16SE1001D
RS1/16SS###J
CAPACITORS
C
C
C
C
C
5,9,15-18
6,10,137,138
7,8,23,40
11-13,55,56
14,30-33
C 21
CKSRYB104K50
CEHAZL101M25
CEHAZA101M16
CKSSYB102K50
CKSSYB103K16
CEHAZL471M16
BDP-05FD
1
2
3
4
5
Mark No. Description
6
Part No.
C
C
C
C
26,27,123,124
28,29,34,37
35,38,132,135
41
VCH1249
CKSRYB104K50
CKSSYB331K50
CEHAZA101M16
C
C
C
C
C
42
43-48,51,52
49,50,53,54
57-64,153-160
65-80,161-176
CEAT470M16
CKSRYB104K50
CEHAZL100M50
CEAT100M50
VCE1053
C
C
C
C
C
89-96,109-112
97-104,193-200
113-116,209-212
125,126,131,134
127-130
VCH1247
CCSSCH220J50
CEANP470M25
CKSRYB104K50
CKSSYB103K16
C
C
C
C
C
139-144,147,148
145,146,149,150
151,152,220
185-192,205-208
221
CKSRYB104K50
CEHAZL100M50
CKSSYB102K50
VCH1247
CKSRYB105K16
D AUJB ASSY (BDP-51FD)
SEMICONDUCTORS
IC 1-3
IC 6,7,14,15
IC 8-13,16-21
Q 1,2,11,12
TC7SHU04FUS1
NJM78M05FA
WM8740SEDS
NJM5532MD
2SC4081
Q 3,4,13,14
Q 5-10,15-18
D 3,4
2SA1576A
2SD2114K
1SS355
> IC 5
7
Mark No. Description
21
26,27,123,124
28,29,34,37
35,38,132,135
41
CEHAZL471M16
VCH1249
CKSRYB104K50
CKSSYB331K50
CEHAZA101M16
C
C
C
C
C
42
43-48,51,52
49,50,53,54
57-64,153-160
65-80,161-176
CEAT470M16
CKSRYB104K50
CEHAZL100M50
CEAT100M50
VCE1053
C
C
C
C
C
89-96,109-112
97-104,193-200
113-116,209-212
125,126,131,134
127-130
VCH1247
CCSSCH220J50
CEANP470M25
CKSRYB104K50
CKSSYB103K16
C
C
C
C
C
139-144,147,148
145,146,149,150
151,152,220
185-192,205-208
221
CKSRYB104K50
CEHAZL100M50
CKSSYB102K50
VCH1247
CKSRYB105K16
CN 1
CHIP BEADS
JACK
JACK
JACK
SCREW PLATE
DTF1070
VKB1159
VKB1130
VKB1265
VNE1948
27P CONNECTOR
VKN1617
A
B
F CAPK ASSY (BDP-05FD Only)
MISCELLANEOUS
CN 1,2
5P CONNECTOR
VKN1374
C
RESISTORS
RS1/16SS###J
CAPACITORS
C 1
C 2,4-6
C 3
MISCELLANEOUS
1-4
1,2
3
4
3,4
Part No.
C
C
C
C
C
All Resistors
L
JA
JA
JA
KN
8
CKSSYB272K50
CKSSYB104K16
CKSSYB105K6R3
G SYPS ASSY
SYPS ASSY has no service part.
D
RESISTORS
R
R
R
R
R
1,2,23-25
3
4,5,10-12
15,28,29
54-61,160-167
RS1/16S470J
RS1/16S101J
RS1/10S0R0J
RS1/16S0R0J
RS1/16S1002D
R
R
R
R
R
62,63,168,169
64-79,170-185
80-83
84,85,186,187
86-89,188-191
RS1/16S472J
RS1/16S4300D
RS1/16S0R0J
RS1/16S332J
RS1/16S6800D
R 90-97,192-199
R 98,99,200,201
R 100-107,202-209
R 108-115,210-217
Other Resistors
RS1/16S1500D
RS1/16S103J
RN1/16SE1301D
RN1/16SE1001D
RS1/16SS###J
E
CAPACITORS
C
C
C
C
C
5,9,15-18
6,10,137,138
7,8,23,40
11-13,55,56
14,30-33
CKSRYB104K50
CEHAZL101M25
CEHAZA101M16
CKSSYB102K50
CKSSYB103K16
F
127
BDP-05FD
5
6
7
8