No category

S IC-F3018 SERVICE MANUAL - R

Transcript

VHF TRANSCEIVER
S-14111IZ-C1-w
Mar. 2008
INTRODUCTION
This service manual describes the latest service information
for the IC-F14/S IC-F15/S IC-F16/S IC-F3018 VHF
TRANSCEIVER at the time of publication.
CHANNEL
SPACING
MODEL VERSION
IC-F14
IC-F15
IC-F16
IC-F14S
IC-F15S
IC-F16S
IC-F3018
USA-02
USA-03
USA-04
GEN-02
EUR-02
RUS-02
RUS-05
CHN-02
USA-02
USA-03
GEN-02
EUR-02
RUS-02
RUS-05
CHN-01
CHANNELS
15.0/30.0 kHz
12.5/25.0 kHz
12.5/20.0/25.0 kHz
16CH
12.5/25.0 kHz
15.0/30.0 kHz
12.5/25.0 kHz
12.5/20.0/25.0 kHz
2Ch
12.5/25.0 kHz
16CH
To upgrade quality, any electrical or mechanical parts and
internal circuits are subject to change without notice or
obligation.
CAUTION
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than specifed. This will ruin
the transceiver.
DO NOT expose the transceiver to rain, snow or any liquids.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100 mW) to
the antenna connector. This could damage the transceiver’s
front-end.
(IC-F14)
ORDERING PARTS
REPAIR NOTES
Be sure to include the following four points when ordering
replacement parts:
1. Make sure that the problem is internal before
disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is
disconnected from its power source.
3. DO NOT force any of the variable components. Turn
them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An
insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the
transceiver is defective.
6. DO NOT transmit power into a Standard Signal
Generator or a Sweep Generator.
7. ALWAYS connect a 50 dB to 60 dB attenuator between
the transceiver and a Deviation Meter or Spectrum
Analyzer when using such test equipment.
8. READ the instructions of test equipment throughly
before connecting a test equipment to the transceiver.
1. 10-digit Icom parts numbers
2. Component name
3. Equipment model name and unit name
4. Quantity required
<ORDER EXAMPLE>
1110003491 S.IC
TA31136FNG IC-F14
8820001210 Screw 2438 screw
IC-F14
MAIN UNIT
5 pieces
Top cover
10 pieces
Addresses are provided on the inside back cover for your
convenience.
Icom, Icom Inc. and
logo are registered trademarks of Icom Incorporated (Japan) in the United States, the United
Kingdom, Germany, France, Spain, Russia and/or other countries.
TABLE OF CONTENTS
SECTION
1
SPECIFICATIONS
SECTION
2
INSIDE VIEWS
SECTION
3
DISASSEMBLY INSTRUCTIONS
SECTION
4
CIRCUIT DESCRIPITON
4-1
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4-2
TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
4-3
PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-4
POWER SUPPLY CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
4-5
OTHER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
4-6
PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5-2
FREQUENCY ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
5-3
TRANSMIT ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
5-4
RECEIVE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
SECTION
6
PARTS LIST
SECTION
7
MECHANICAL PARTS
SECTION
8
BOARD LAYOUTS
8-1
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
8-2
ANT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
8-3
CONNECT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
SECTION
9
BLOCK DIAGRAM
SECTION
10
VOLTAGE DIAGRAM
SECTION
11
BC-160
SECTION
SECTION 1.
GENERAL
•
•
•
•
•
•
Frequency coverage
Mode
Channel spacing
Number of conventional channels
Antenna impedance
Operating temperature range
• Power supply requirement
• Current drain (at 7.2 V DC ; approx.)
SPECIFICATIONS
: 136.000–174.000 MHz
: FM
: (Refer to the "INTRODUCTION")
: 16 ch/2 ch (Refer to the "INTRODUCTION")
: 50 Ω
: –30˚C to +60˚C (–22˚F to +140˚F)
[F14/S, F16/S, F3018]
–25˚C to +55˚C
[F15/S]
: Specified Icom's battery pack only (7.2 V DC nominal; negative ground)
:
RECEIVING
TRANSMITTING
Stand-by
70 mA
• Dimensions (projections not included)
• Weight (Including BP-231)
Max. audio
300 mA
High (at 5 W)
1.5 A
: 53(W)×120(H)×38(D) mm; 2 3⁄32(W)×4
: Approx. 260 g (93⁄16 oz)
23⁄
Low (at 1 W)
0.7 A
32(H)×1
1⁄
2(D)
in
TRANSMITTER
•
•
•
•
•
Output power (at 7.2 V DC)
Modulation
Maximum permissible deviation
Frequency error
Spurious emissions
:5W
: Variable reactance frequency modulation
: ±5.0 kHz (Wide), ±4.0 kHz (Middle), ±2.5 kHz (Narrow)
: ±2.5 ppm
: 80 dB (typical)
[F14/S, F16/S, F3018]
0.25 µW (≤ 1 GHz), 1.0 µW (> 1 GHz)
[F15/S]
• Adjacent channel power
: 70 dB min. (80dB typ.) for Wide and Middle
60 dB min. (70dB typ.) for Narrow
• Audio harmonic distortion
: 3% typical (1 kHz, 40% deviation)
• Hum and Noise ([F14/S, F16/S, F3018]) : 40 dB min. (46 dB typ.) for Wide
(without CCITT filter)
34 dB min. (40 dB typ.) for Narrow
• Residual modulation ([F15/S])
: 45 dB min. (55 dB typ.) for Wide
(with CCITT filter)
43 dB min. (53 dB typ.) for Middle
40 dB min. (50 dB typ.) for Narrow
• Limiting charact of modulator
: 60–100% of maximum deviation
• Microphone impedance
: 2.2 kΩ
RECEIVER
• Receive system
• Intermediate frequencies
• Sensitivity
•
•
•
•
•
•
•
•
: Double conversion superheterodyne system
: 1st IF: 46.35 MHz, 2nd IF: 450 kHz
: 0.25 µV (–119 dBm) typical at 12 dB SINAD
–4 dBµ (–111 dBm) emf typical at 20 dB SINAD
Adjacent channel selectivity
: 70 dB min. (75 dB typ.) for Wide and Middle
60 dB min. (65 dB typ.) for Narrow
Spurious response
: 70 dB min.
Intermodulation rejection ratio
: 70 dB min. (74 dB typ.)
65 dB min. (67 dB typ.)
Hum and Noise ([F14/S, F16/S, F3018]) : 40 dB min. (50 dB typ.) for Wide
(without CCITT filter)
34 dB min. (45 dB typ.) for Narrow
Hum and Noise ([F15/S])
: 45 dB min. (55 dB typ.) for Wide
(with CCITT filter)
43 dB min. (53 dB typ.) for Middle
40 dB min. (50 dB typ.) for Narrow
Audio output power
: 0.5 W typical at 5% distortion with an 8 Ω load
Squelch sensitivity (at threshold)
: 0.25 µV typical
–4 dBµV emf typical
Output impedance (Audio)
:8Ω
Specifications are measured in accordance with EIA-152-C/204D, TIA-603 or EN 300 086.
All stated specifications are subject to change without notice or obligation.
1-1
[F14/S, F16/S, F3018]
[F15/S]
[F14/S, F16/S, F3018]
[F15/S]
[F14/S, F16/S, F3018]]
[F15/S]
SECTION 2.
INSIDE VIEWS
• MAIN UNIT
TOP VIEW
BOTTOM VIEW
TX/RX switches
(D14, D15: MA2S077)
Pre-driver
(Q9: 2SC5110)
Power amplifier
(Q7: RD07MVS1)
AF amplifier
(IC12: TA7368F)
+5 Regulator
(IC9: NJM2870)
S5 Regulator
Q23: 2SB1132
Q24: XP6501
Q25: UNR9113J
T5 Regulator
(Q21: 2SA1577)
Crystal filter
(FI1: FL-335)
Mute switch
(Q6: UNR9113J)
APC amplifier
(IC2: TA75S01F)
FM IF IC
(IC1: TA31136FN)
VCO circuit
IF amplifier
(Q4: 2SC5107)
D/A converter
(IC8: M62363FP)
PLL IC
(IC4: MB15A02)
R5 Regulator
(Q22: 2SA1577)
EEPROM
(IC15: BR24L16FV)
CPU
(IC13: HD6433687)
2-1
SECTION 3.
DISASSEMBLY INSTRUCTION
1. REMOVING THE CHASSIS UNIT
2. REMOVING THE MAIN UNIT
q Unscrew 1 nut A, and remove 2 knobs B, C.
w Unscrew 2 screws D.
e Take off the chassis unit in the direction of the arrow.
r Unplug the connector E from the chassis unit.
q Unscrew 2 nuts F, and remove the top plate G.
w Unsolder 5 points H, and remove the shield cover.
e Unscrew 2 screws I, and remove the side plate J.
r Unscrew 7 screws K.
t Unsolder 4 points L, and take off the main unit in the
direction of the arrow.
Chassis unit
C
*B
A
E
D
Shield cover
H
H
I
K
L
J
K
L
K
*: IC-F14/F15/F16/F3018 only
Main unit
F
G
Chassis unit
3-1
SECTION 4.
CIRCUIT DESCRIPTION
The RF signals from the bandpass filter are mixed with
the 1st LO signals, where come from the RX VCO circuit
via the attenuator (R26–R28), at the 1st mixer circuit (Q3)
to produce a 46.35 MHz 1st IF signal. The 1st IF signal is
passed through a monolithic filter (FI1) in order to obtain
selection capability and to pass only the desired signal.
The filtered signal is applied to the 2nd IF circuit after being
amplified at the 1st IF amplifier (Q4).
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
The antenna switching circuit functions as a low-pass filter
while receiving and a resonator circuit while transmitting.
This circuit does not allow transmit signals to enter the
receiver circuits.
Received signals enter the antenna connector (CHASSIS;
J1) and pass through the low-pass filter (L1–L3, C2–C5,
C175, C176). The filtered signals are passed through the
1⁄4λ type antenna switching circuit (D5, D6, L6, L7) and
then applied to the RF circuit.
4-1-4 2ND IF AND DEMODULATOR CIRCUITS
The 2nd mixer circuit converts the 1st IF signal into a 2nd
IF signal. The double-conversion superheterodyne system
(which convert receive signals twice) improves the image
rejection ratio and obtains stable receiver gain.
4-1-2 RF CIRCUIT
The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals.
The 1st IF signal from the IF amplifier (Q4) is applied to
the 2nd mixer section of the FM IF IC (IC1, pin 16), and
is mixed with the 2nd LO signal to be converted into a
450 kHz 2nd IF signal.
The signals from the antenna switching circuit pass through
the bandpass filter (D4, D8, L8, L9). The filtered signals are
amplified at the RF amplifier (Q2) and then passed through
the another bandpass filter (D9, D10, L11) to suppress
unwanted signals. The filtered signals are applied to the 1st
mixer circuit.
The FM IF IC (IC1) contains the 2nd mixer, 2nd local oscillator, limiter amplifier, quadrature detector, active filter and
noise amplifier circuits. A 2nd LO signal (45.9 MHz) is produced at the PLL circuit by tripling it’s reference frequency
(15.3 MHz).
D4, D8–D10 employ varactor diodes, that are controlled by
the CPU via the D/A converter (IC8), to track the bandpass
filter. These varactor diodes tune the center frequency of an
RF passband for wide bandwidth receiving and good image
response rejection.
The 2nd IF signal from the 2nd mixer (IC1, pin 3) passes
through the ceramic filter (FI2) to remove unwanted heterodyned frequencies. It is then amplified at the limiter
amplifier section (IC1, pin 5) and applied to the quadrature
detector section (IC1, pins 10, 11) to demodulate the 2nd
IF signal into AF signals.
4-1-3 1ST MIXER AND 1ST IF CIRCUITS
The 1st mixer circuit converts the received signal into fixed
frequency of the 1st IF signal with the PLL output frequency. By changing the PLL frequency, only the desired
frequency passes through a crystal filter at the next stage
of the 1st mixer.
The demodulated AF signals are output from pin 9 (IC1) as
“DET” signal, and are then applied to the AF circuit.
2ND IF AND DEMODULATOR CIRCUITS
2nd IF filter
450 kHz
Q19
45.9 MHz
FI2
8
7
Noise
AMP
Active
filter
"SQLC" signal from the
D/A converter IC
(IC8, pin 2)
3
5
X2
15.3 MHz
×3
2
Noise
detector
Mixer
Limiter
AMP
Noise
comparator
FM
detector
RSSI
IC1 TA31136FN
To D/A converter IC
(IC8, pin 1)
9
10
11
12
13
16
1st IF signal from the IF amplifier (Q4)
"NOIS" signal to the CPU (IC13, pin 53)
AF signal "DET"
to the AF circuit
R5V
"RSSI" signal to the CPU (IC13, pin 63)
X1
4-1
• CTCSS AND DTCS
The tone squelch circuit detects tone signals and opens the
squelch only when receiving a signal containing a matched
subaudible tone (CTCSS or DTCS). When tone squelch is
in use, and a signal with a mismatched or no subaudible
tone is received, the tone squelch circuit mutes the AF signals even when noise squelch is open.
4-1-5 AF AMPLIFIER CIRCUIT
The AF amplifier circuit amplifies the demodulated AF signals to drive a speaker.
The AF signals from the FM IF IC (IC1, pin 9) pass through
the high-pass filter (IC6, pins 3 and 1) to suppress unwanted harmonic components. The signals pass through the
RX mute switch (Q34) which is controlled by “RMUT” signal from the CPU (IC13, pin 56), and are then applied to
another high-pass filter (IC6, pins 13 and 14). The filtered
signals pass through the low-pass filter (IC6, pins 6 and
7) via the analog switch (IC10, pins 1 and 2). The signals
are applied to the analog switch (IC10, pin 10) again, and
are then applied to the AF power amplifier (IC12, pin 4) via
the AF volume (R226). The amplified AF signals are output
from pin 10, and are then applied to the internal speaker
which is connected with J1 via the [SP] jack.
A portion of the “DET” signals from the FM IF IC (IC1, pin
9) passes through the low-pass filter (IC7, pins 10 and 8)
to remove AF (voice) signals, and are then applied to the
amplifier (IC7, pin 12). The amplified signals are applied to
the CTCSS or DTCS decoder inside of the CPU (IC13, pin
60) as the “CDEC” signal. The CPU outputs AF mute control signal, and is then applied to the RX mute switch (Q34)
and analog switch (IC10, pins 12 and 13) to control AF signals muting as “RMUT” signal.
4-1-6 RECEIVE MUTE CIRCUITS
4-2 TRANSMITTER CIRCUITS
• NOISE SQUELCH
A squelch circuit cuts out AF signals when no RF signals
are received. By detecting noise components in the AF signals, the squelch circuit switches the AF mute switch.
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
The microphone amplifier circuit amplifies audio signals
within +6 dB/octave pre-emphasis characteristics from the
microphone to a level needed for the modulation circuit.
Some noise components in the AF signals from the FM IF
IC (IC1, pin 9) are applied to the D/A converter (IC8, pin
1) as “DET” signal, and are then output from pin 2. The
signals are applied to the active filter section in the FM IF
IC (IC1, pin 8). The active filter section filters and amplifies
noise components. The amplified signals are converted into
the pulse-type signals at the noise detector section and
output from pin 13 as “NOIS” signal.
The AF signals from the microphone are passed through
the microphone mute switch (Q35), and are then applied
to the amplifier (IC6, pins 9 and 8) via the high-pass filter
(IC6, pins 13 and 14). The amplified signals are applied to
the analog switch (IC10, pin 4), and outputs from pin 3. The
signals pass through the low-pass filter (IC6, pins 6 and
7), then applied to the analog switch (IC10, pin 9) again.
The signals are applied to the D/A converter (IC8, pin 4).
The converted signals output from pin 3, and applied to the
modulation circuit (D18) as “MOD” signal.
The “NOIS” signal from the FM IF IC is applied to the CPU
(IC13, pin 53). Then the CPU analyzes the noise condition
and outputs the AF mute control signal from the CPU (pin
56) as “RMUT” signal. The signal is applied to the RX mute
switch (Q34) to control the AF signal muting.
ANALOG SWITCHING CIRCUITS
"DET" AF signal
from FM IF IC (IC1, pin 9)
IC6 A
Q34
HPF
RX
MUTE
IC6 B
LPF
2
1
3
IC6 D
Q35
HPF
MIC
MUTE
Microphone
IC6 C
Analog SW
(IC10)
9
AMP
4
AF
volume
10
11
8
IC12
AF
AMP
R226
IC8
D/A converter
D18
to TX VCO circuit
(Q13, D16, D17)
FM mod.
"CTCSS/DTCS" signal from
D/A conveter IC (IC8, pin 10)
"TONE" signal from CPU (IC13) via low-pass
filters (IC5 A / IC5 B pin 7)
4-2
Speaker
4-2-2 MODULATION CIRCUIT
4-2-4 APC CIRCUITS
The modulation circuit modulates the VCO oscillating signal
(RF signal) using the microphone audio signals.
The AF signals from the D/A converter (IC8, pin 3) change
the reactance of varactor diode (D18) to modulate the oscillated signal at the TX VCO circuit (Q13, D16, D17). The
modulated VCO signal is amplified at the buffer amplifiers
(Q12, Q10) and is then applied to the drive amplifier circuit
via the T/R switch (D14).
The APC circuit (IC2, D1) protects drive and power amplifiers from the reflected signal, and selects output power of
HIGH, LOW2 or LOW1.
The power detector (D1) detects transmit output power and
converts it into DC voltage. The DC voltage is at a minimum
level when the antenna impedance is matched to 50 Ω, and
increased when mismatched.
The CTCSS/DTCS signals (“CENC0”, “CENC1”, ”CENC2”)
from the CPU (IC13, pins 23–25) pass through the low-pass
filter (IC5, pins 12 and 14) via 3 registers (R191–R193) to
change its wave form. Then the signals are applied to the
D/A converter (IC8, pin 9). The output signals from the D/A
converter (IC8, pin 10) pass through the low-pass filter (IC6,
pins 6 and 7) to be mixed with “MOD” signal at the filter (IC6),
and are then applied to the D/A converter again (IC8, pin 4).
The detected voltage is applied to the differential amplifier (IC2, pin 3), and the “T2” signal from the D/A converter
(IC8, pin 23), controlled by the CPU (IC13), is applied to the
other input for reference. When antenna impedance is mismatched, the detected voltage exceeds the power setting
voltage. Then the output voltage of the differential amplifier
(IC2, pin 4) controls the input current of the pre-drive (Q9),
drive (Q8) and power (Q7) amplifiers to reduce the output
power.
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
The drive/power amplifier circuits amplify the VCO oscillating signal to an output power level.
The modulated RF signal from the TX VCO circuit passes
through the T/R switch (D14), and is amplified at the predrive (Q9), drive (Q8) and power (Q7) amplifiers to obtain
5 W of RF power (at 7.2 V DC).
The amplified signal passes through the power detector (D1),
antenna switch (D2) and low-pass filter (L1–L3, C2–C5,
C175, C176), and is then applied to the antenna connector
(CHASSIS unit; J1).
The bias current of the pre-drive (Q9), drive (Q8) and power
(Q7) amplifiers are controlled by the APC circuit.
APC CIRCUITS
VCC
T5V
Q9
YGR
AMP
RF signal
from Buffer AMP
Q8
Driver
AMP
Q7
Power
AMP
ANT
SW
LPF
D2
T2
TMUT
+
IC2
Differential
AMP
D1
–
4-3
LPF
to ANT unit
4-3 PLL CIRCUITS
4-3-2 VCO CIRCUIT
4-3-1 PLL CIRCUIT
A PLL circuit provides stable oscillation of the transmit
frequency and receive 1st LO frequency. The PLL output
compares the phase of the divided VCO frequency to the
reference frequency. The PLL output frequency is controlled
by the divided ratio (N-data) of a programmable divider.
The VCO circuit contains a separate RX VCO (Q14, D19,
D20) and TX VCO (Q13, D16, D17). The oscillated signal
is amplified at the buffer amplifiers (Q10, Q12) and is then
applied to the T/R switch (D14 for TX, D15 for RX). Then the
receive 1st LO (RX) signal is applied to the 1st mixer circuit
(Q3) and the transmit (TX) signal to the pre-drive amplifier
(Q9).
The PLL circuit contains the TX/RX VCO circuits (TX: Q13,
D16, D17, D21; RX: Q14, D19, D20, D22). The oscillated
signal is amplified at the buffer amplifiers (Q11, Q12) and
then applied to the PLL IC (IC4, pin 8) after being passed
through the low-pass filter (L32, C206–C208).
A portion of the signal from the buffer amplifier (Q12) is fed
back to the PLL IC (IC4, pin 8) via the buffer amplifier (Q11)
and low-pass filter (L32, C206–C208) as the comparison
signal.
The phase detected signal outputs from pins 15 and 16, and
is then applied to the charge pump (Q39, Q40). The signal
passes through the loop filter (C146, C147, C149, R95–
R97), and is then applied to the TX and RX VCO circuits as
a lock voltage.
The PLL IC contains a prescaler, programmable counter,
programmable divider and phase detector, etc. The entered
signal is divided at the prescaler and programmable counter
section by the N-data ratio from the CPU. The divided signal
is detected on phase at the phase detector using the reference frequency.
If the oscillated signal drifts, its phase changes from that of
the reference frequency, causing a lock voltage change to
compensate for the drift in the oscillated frequency.
PLL CIRCUITS
RX VCO
Buffer
Q10
Q14, D19, D20, D22
Buffer
Q18
"LVIN" signal to the CPU
(IC13, pin 64)
D14
Buffer
Q12
TX VCO
D15
Buffer
Q11
Loop
filter
Q13, D16, D17, D21
LPF
Charge
Pump
Q39, Q40
IC4 MB15A02
15
16
45.9 MHz 2nd LO
signal to the FM IF IC Tripler
(IC1, pin 2)
3
Phase
detector
Programmable
counter
Programmable
divider
Prescaler
Shift register
2
8
14 SCK
15 SO
16 PLST
1
X2
15.3 MHz
Q19
4-4
to 1st mixer circuit
to transmitter circuit
4-4 OTHER CIRCUITS
4-6 PORT ALLOCATION
LED CONTROL CIRCUITS
4-6-1 D/A CONVERTER IC (IC8)
The LED control circuit is composed of the CPU (IC13),
LED driver (Q32) and LED (DS1).
The CPU outputs “RLED” and “TLED” signals from the pins
42 and 43. The signals are applied to the LED driver (Q32,
pins 3 and 1). The driver outputs LED control signals to the
LED (DS1).
CONDITION
RECEIVING (2/5-TONE CODE)
LOW BATTERY
(Nearly exhausted)
LOW BATTERY
(Almost exhausted)
CLONING
RECEIVING/SQUELCH OPEN
TRANSMITTING
COLOR
ORANGE (Lighting)
Description
11
BAL
Outputs the modulation balance level
control signal. The signal is applied to
the buffer amplifier (IC7, pin 3).
23
T2
• Outputs the bandpass filter tuning
signal during receive. The output
signal is applied to the bandpass
filters (D9, D10).
• Outputs the TX power control signal
during transmit. The output signal is
applied to the APC amplifier (IC2,
pin 1).
22
T1
Outputs the bandpass filter tuning
signal. The output signal is applied to
the bandpass filters (D4, D8).
14
LVA
Outputs the PLL lock voltage control
signal. The output signal is applied to
the buffer amplifier (IC7, pin 3).
15
REF
Outputs the reference oscillator
correcting voltage. The voltage is applied
to the buffer amplifier (IC7, pin 5).
RED (Blinks Fast)
ORANGE (Blinking)
GREEN (Lighting)
RED (Lighting)
VOLTAGE LINE
DESCRIPTION
VCC
The voltage from the connected battery pack.
+5V
Common 5 V converted from the VCC line at
the +5 regulator circuit (IC9). The output voltage
is supplied to the D/A converter (IC8), analog
SW (IC10) and so on.
S5V
Common 5 V converted from the VCC line at
the S5 regulator circuit (Q23–Q25). The output
voltage is supplied to the ripple filter (Q17), PLL
IC (IC4), etc.
R5V
Receive 5 V converted from the S5V line at the
R5 regulator circuit (Q22). The output voltage
is supplied to the tripler (Q19), FM IF IC (IC1),
IF amplifier (Q4), VCO switch (Q15, Q16), 1st
mixer (Q3), etc.
T5V
Port
name
RED (Blinks Slowly)
4-5 POWER SUPPLY CIRCUIT
LINE
Pin
number
Transmit 5 V converted from the S5V line at the
T5 regulator circuit (Q21). The output voltage
is supplied to the pre-drive (Q9), APC amplifier
(IC2).
4-5
4-6-2 CPU (IC13)
Pin
number
Port
name
1
TEMP
2
BATV
7
13
14
RES
SENC0
SENC1
16
DUSE
17
BUSY
18
AFON
19
SENC2
20
SENC3
21
CBI0
22
CBI1
23
CENC0
24
CENC1
25
CENC2
26
CBI2
27
CBI3
28
SCK
29
SO
30
BEEP
31
ESDA
32
ESCL
33
UNLK
34
PLST
36
NWC
37
DAST
38
S5C
39
T5C
40
R5C
Description
Pin
number
Input port for the transceiver’s
internal temperature detecting
signal.
Input port for the detect signal for
connecting battery pack’s voltage.
Input port for power reset signal.
42
RLED Outputs receiving LED control signal.
43
TLED
44
45
46
OPT3
OPT1 I/O ports for option unit.
OPT2
Input port for the PTT switch detection
PTT signal.
Low : While the PTT switch is pushed.
Serial Bus inputport.
SI
CLI Input port for the cloning data signal.
CLO Outputs the cloning data signal.
Input port for the noise signal from the
NOIS
FM IF IC (MAIN unit; IC1, pin 13).
Output single tone encoder
signal.
Outputs DTSC LPF control
signal.
47
48
49
50
Outputs AF power amplifier
control signal.
Port
name
Description
Outputs transmitting LED control
signal.
Output single tone encoder
signal.
53
54
CIRQ Input port for option unit detection.
Input ports for ritary selectoir.
55
CCS Outputs chip select signal.
Output CTCSS/DTCS signals.
Input ports for ritary selectoir.
Outputs serial clock signal to the
PLL IC (IC4, pin 9), D/A convertor
(IC6, pin 7), etc.
Outputs serial data to the PLL IC
(IC6, pin 8) and D/A convertor
(IC6, pin 8).
56
TMUT Outputs transmit mute signal.
57
RMUT
58
MMUT Outputs MIC mute signal.
59
REMO Inputs key signal from remote mic.
60
CDEC
61
Outputs beep audio signals.
I/O port for data signals from/to
the EEPROM (IC15, pin 5).
Outputs clock signal to the
EEPROM (IC15, pin 6).
Input port for unlock signal from
PLL IC.
Outputs strobe signals to the PLL
IC (IC4, pin 11).
Output/input port for wide/narrow
control signal.
• Outputs strobe signals to the
D/A convertor (IC8, pin 6).
• Input port for the connecting
battery type detect signal.
Outputs power save control
signal.
Outputs T5 regurator control
signal.
Low: While transmitting
Outputs R5 regurator control
signal.
Low: While receivinging
4-6
Input port for AF mute signal from the
RX circuit.
Input port for CTCSS/DTCS signal
from the amplifier (IC5, pin 8).
Input port for single tone decode
SDEC
signal from the LPF (IC5, pin 8).
62
KEY
Inputs key input signal.
63
RSSI
Input port for the S-meter signal from
the FM IF IC (IC1, pin 12).
64
LVIN Input port for the PLL lock voltage.
SECTION 5.
ADJUSTMENT PROCEDURE
5-1 PREPARATION
¤ REQUIRED EQUIPMENTS
EQUIPMENT
EQUIPMENT
SPECIFICATION
SPECIFICATION
Adjustment
Software
"CS-F14 ADJ" (Revision 1.0 or later)
JIG cable
(see the page 5-3)
Modified OPC-478U/UC (USB type) or
OPC-478 (RS-232 type)
Audio Generator
Frequency range
Output level
: 300–3000 Hz
: 1–500 mV
Attenuator
Power attenuation : 30 dB
Capacity
: More than 6 W
RF Power Meter
(terminated type)
Measuring range
Frequency range
Impedance
SWR
: 1–6 W
: 100–300 MHz
: 50 Ω
: Less than 1.2 : 1
Standard Signal
Generator (SSG)
Frequency range : 0.1–300 MHz
Frequency Counter Frequency accuracy : ±1 ppm or better
Input level
: Less than 1 mW
Modulation
Analyzer
Frequency range
Measuring range
: 30–300 MHz
: 0 to ±10 kHz
Frequency range
Output level
: 0.1–300 MHz
: 0.1 mV to 32 mV
(–127 to –17 dBm)
AC Millivoltmeter
Measuring range
: 10 mV to 10 V
Oscilloscope
Frequency range
Measuring range
: DC–20 MHz
: 0.01–20 V
External Speaker
Input impedance
Capacity
:8Ω
: More than 5 W
SYSTEM REQUIREMENTS
• Microsoft® Windows® 98/SE/ME/2000/XP
• RS232C/USB port
BEFORE STARTING SOFTWARE ADJUSTMENT
Clone adjustment freqencies, TX power, CTCSS frequency,
DTCS code and IF bandwidth into the transceiver using with
the CS-F14 CLONING SOFTWARE before starting adjustment.
See the next page for detail.
CAUTION!: BACK UP the originally programmed memory
data in the transceiver before programming
the adjustment frequencies.
When program the adjustment frequencies
into the transceiver, the transceiver’s memory
data will be overwritten and lose original
memory data at the same time.
Microsoft, Windows and Windows Vista are either registered
trademarks or trademarks of Microsoft Corporation in the
United States and/or other countries.
5-1
¤ ADJUSTMENT CHANNELS
Create "icf" file/files for adjustment as below, then clone it into the transceiver before starting adjustment.
<For IC-F14/F15/F16/F3018>
<For IC-F14S/F15S/F16S>
q Assigne MR-CH3/MR-CH4 to the [Upper]/[Lower] keys.
q Create the icf file "F14 ADJ CH.icf."
“F14 ADJ CH.icf”
w Create five icf files as below.
“ADJ CH FREQ.icf”
w Clone the icf file into the transceiver.
“ADJ CH TXPWR.icf”
“ADJ CH AudioMOD.icf”
“ADJ CH ToneMOD.icf”
“ADJ CH RX.icf”
5-2
(CONNECTION
AC millivoltmeter
To [MIC]
Audio generator
OPC-478
(RS-232C type)
Standard signal generator
0.1 µV to 32 mV
(–127 dBm to –17 dBm)
PC
to the antenna connector
to USB port
OPC-478U
(USB type)
DO NOT transmit while
an SSG is connected to
the antenna connector.
FM
deviation meter
to RS-232C port
to USB port
Attenuator
20 dB / 30 dB
OPC-478UC
(USB type)
RF power meter
0.1–10 W/50 Ω
Frequency
counter
To [SP] connector
SINAD meter
To [SP]
JIG cable
Speaker (8 Ω)
(JIG CABLE
( SP + )
(SP − )
(GND)
3-conductor 3.5(d) mm plug
To [SP] jack
OPC-478/U/UC
JIG cable
(CLONE)
5-3
P
STARTING SOFTWARE ADJUSTMENT
(1) Connect the transceiver and PC with OPC-478/U/UC and JIG CABLE (see the previous page).
(2) Turn the transceiver power ON.
(3) Boot up Windows, and click the program group 'CS-F14 ADJ’ in the ‘Programs’ folder of the [Start] menu, then CS-F14 ADJ’s
window appears.
(4) Click ‘Connect’ on the CS-F14’s window, then IC-F14’s up-to-date condition appears as below.
(5) Set or modify adjustment value as specified in following guidances.
(ADJUSTMENT WINDOW
NOTE: The above screen is an example.
Each transceiver has its own specific values for each setting.
5-4
5-2 FREQUENCY ADJUSTMENT
1) Select an adjustment item using cursor or [↑] / [↓] keys of the PC’s keyboard.
2) Set or modify the adjustment value as specified using [←] / [→] keys of the PC’s keyboard, then push the [ENTER] key.
ADJUSTMENT
PLL LOCK
VOLTAGE
-Preparation-
-AdjustRX
TX
ADJUSTMENT CONDITION
OPERATION
VALUE
–
–
[RX LVA]
3.5 V
(at the "LVIN"
item)
1 <For IC-F14S/F15S/F16S only>
Clone the "ADJ CH FREQ.icf" into the transceiver.
2 • Connect an RF Power Meter to
the antenna.
–
2 • CH. (16CH/2CH) : CH.1/CH.1 • Monitoring lock voltage at the "LVIN"
• Receiving
in the "ADJUSTMENT WINDOW"
(see the previous page), adjust the
[RX LVA] using [←] / [→] keys on the
PC’s keyboard.
or
• Set the [RX LVA] to "179", then
push the [ENTER] key.
3 • CH. (16CH/2CH) : CH.1/CH.1 • Monitoring lock voltage at the "LVIN"
• Transmitting
in the "ADJUSTMENT WINDOW"
(see the previous page), adjust the
[TX LVA] using [←] / [→] keys on the
PC’s keyboard.
or
• Set the [TX LVA] to "179", then push
the [ENTER] key.
1 <For IC-F14S/F15S/F16S only>
LOCK
VOLTAGE
Clone the "ADJ CH FREQ.icf" into the transceiver.
VERIFICATION
• CH. (16CH/2CH) : CH.2/CH.2 • Verify the lock voltage at the "LVIN"
• Receiving
in the "ADJUSTMENT WINDOW"
RX
(see the previous page).
TX
2 • CH. (16CH/2CH) : CH.2/CH.2
• Transmitting
REFERENCE
FREQUENCY
ADJUSTMENT
ITEM
1
–
• Connect an RF Power Meter to the
antenna.
2 • CH. (16CH/2CH) : CH.1/CH.1 1) Adjust the frequency using [←] / [→]
• Transmitting
keys on the PC’s keyboard.
2) Push the [ENTER] key to store the
adjust value.
5-5
or
[TX LVA]
[LVIN]
"179"
(at the [RX/TX
LVA])
0.9–1.5 V
(Verify)
3.0–4.0 V
(Verify)
–
–
[REF]
173.9000 MHz
5-3 TRANSMIT ADJUSTMENT
1) Select an adjustment item using cursor or [↑] / [↓] keys of the PC’s keyboard.
2) Set or modify the adjustment value as specified using [←] / [→] keys of the PC’s keyboard, then push the [ENTER] key.
ADJUSTMENT
ADJUSTMENT
ITEM
VALUE
–
–
[Power (Hi)]
5.0 W
[Power (L2)]
2.0 W
[Power (L1)]
1.0 W
–
–
–
–
[MOD Ratio]
±4.05–4.15
kHz
[MOD Ratio]
±3.15–3.25
kHz
[MOD N]
±2.05–2.15
kHz
• Connect a Modulation Analyzer • Set the Modulation Analyzer as;
to the antenna connector
HPF
: OFF
through an attenuator.
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
–
–
• Connect an Oscilloscope to
the Detect ter minal of the
Modulation Analyzer.
–
–
[BAL N]
Square
waveform
ADJUSTMENT CONDITION
OPERATION
TRANSMIT
OUTPUT
POWER
-Preparation-
1 <For IC-F14S/F15S/F16S only>
-AdjustmentHi
2 • CH. (16CH/2CH) : CH.3/CH.1 1) Adjust the transmit output power
• Transmitting
using [←] / [→] keys on the PC’s
keyboard.
3 • CH. (16CH/2CH) : CH.4/CH.2
2) Push the [ENTER] key to store the
• Transmitting
adjust value.
4 • CH. (16CH/2CH) : CH.5/CH.3
• Transmitting
L2
L1
DEVIATION
-Preparation-
Clone the "ADJ CH TXPWR.icf" into the transceiver.
–
• Connect an RF Power Meter to the
antenna connector.
1 <For IC-F14S/F15S/F16S only>
Clone the "ADJ CH AudioMOD.icf" into the transceiver.
• Connect a Modulation Analyzer • Set the Modulation Analyzer as;
to the antenna connector
HPF
: OFF
through an Attenuator.
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
2 • Connect an Audio Generator • Set the Audio Generator as;
to the MIC line through the JIG
Modulation
: 1 kHz
cable.
Level
: 40 mV rms
Wave form
: Sine wave
-AdjustmentWIDE
MIDDLE*
NARROW
MODULATION
BALANCE
-Preparation-
-AdjustmentNARROW
MIDDLE*
3 • CH. (16CH/2CH) : CH.5/CH.2 1) Adjust the deviation using [←] / [→]
• Transmitting
keys on the PC’s keyboard.
2) Push the [ENTER] key to store the
adjust value.
4 • CH. (16CH/2CH) : CH.6/CH.1
• Transmitting
5 • CH. (16CH/2CH) : CH.7
• Transmitting
1 <For IC-F14S/F15S/F16S only>
Clone the "ADJ CH ToneMOD.icf" into the transceiver.
2 • CH. (16CH/2CH) : CH.8/CH.1 1) Adjust the waveform using [←] / [→]
• Transmitting
keys on the PC’s keyboard.
3 • CH. (16CH/2CH) : CH.8/CH.1 2) Push the [ENTER] key to store the
adjust value.
• Transmitting
WIDE
4 • CH. (16CH/2CH) : CH.9/CH.2
• Transmitting
CTCSS/DTCS
DEVIATION
-Preparation-
1 <For IC-F14S/F15S/F16S only>
-Adjustment-
–
[BAL Ratio]
Flat
[BAL Ratio]
Clone the "ADJ CH ToneMOD.icf" into the transceiver.
• Connect a Modulation Analyzer • Set the Modulation Analyzer as;
to the antenna connector
HPF
: OFF
through an attenuator.
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
–
2 • CH. (16CH/2CH) : CH.10/CH.3 1) Adjust the deviation using [←] / [→]
• Transmitting
keys on the PC’s keyboard.
[CTCSS/DTCS]
2) Push the [ENTER] key to store the
adjust value.
*: F15/S only
5-6
–
±0.66–0.70
kHz
5-2 RECEIVE ADJUSTMENT
1) Select an adjustment item using cursor or [↑] / [↓] keys of the PC’s keyboard.
2) Set or modify the adjustment value as specified using [←] / [→] keys of the PC’s keyboard, then push the [ENTER] key.
ADJUSTMENT
RECEIVE
SENSITIVITY
-Preparation-
-Adjustment-
ADJUSTMENT CONDITION
OPERATION
ADJUSTMENT
ITEM
VALUE
–
–
[BPF (T1)]
[BPF (T2)]
(Automatic
adjustment)
1 <For IC-F14S/F15S/F16S only>
Clone the "ADJ CH RX.icf" into the transceiver.
• C o n n e c t a n S S G t o t h e • Set the SSG as;
antenna connector.
Frequency
: 136.1000 MHz
Level
: +20 dBμ
Modulation
: 1 kHz
Deviation
: 3.5 kHz
2 • CH. (16CH/2CH) : CH.11/CH.1 1) Select the item [BPF (T1)], then
• Receiving
push the [ENTER] key.
2) Select the item [BPF (T2)], then
push the [ENTER] key.
CONVINIENT: [BPF (T1)] and [BPF (T2)] can be adjusted at same time as below.
2 • CH. (16CH/2CH) : CH.11/CH.1 • Select the item [BPF ALL], then
• Receiving
push the [ENTER] key.
SQUELCH
-Preparation-
(Automatic
adjustment)
–
–
[SQL]
(Automatic
adjustment)
1 <For IC-F14S/F15S/F16S only>
Clone the "ADJ CH RX.icf" into the transceiver.
• C o n n e c t a n S S G t o t h e • Set the SSG as;
antenna connector.
Frequency
: 155.0000 MHz
Level
: –14 dBμ
Modulation
: 1 kHz
Deviation
: 3.5 kHz
-Adjustment-
[BPF ALL]
2 • CH. (16CH/2CH) : CH.12/CH.2 1) Decrease the adjustment value
[SQL] to close the squelch once,
• Receiving
then increase the value to open the
squelch.
2) Select the item [SQL], then push
the [ENTER] key to store the adjust
value.
5-7
SECTION 6.
PARTS LIST
[MAIN UNIT]
REF
NO.
[MAIN UNIT]
PARTS
NO.
DESCRIPTION
H/V
M. LOCATION
IC1
IC2
IC4
IC5
IC6
IC7
IC8
IC9
IC10
IC12
IC13
IC14
IC15
1110003201
1110002751
1140005991
1110005340
1110005320
1110005340
1190000350
1110005350
1130011770
1110001811
1140012721
1110006260
1130011540
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
TA31136FNG (EL)
TA75S01F (TE85R,F)
MB15A02PFV1-G-BND-ERE1
NJM12902V-TE1-#ZZZB
NJM13403V-TE1-#ZZZB
NJM12902V-TE1-#ZZZB
M62363FP-650C
NJM2870F05-TE1-#FZZB
CD4066BPWR
TA7368FG (5,ER)
HD6433687C73FPV
BD5242G-TR
BR24L16FV-WE2
B
T
T
T
T
T
T
B
T
T
T
T
B
51.8/19
68.9/21
38.3/35.7
29.7/11.6
16/34.6
29.9/34.6
40.3/15.2
84.2/14.2
22.9/34.6
89.6/13.6
12.5/14.3
6.6/5.9
16/11.6
Q1
Q2
Q3
Q4
Q6
Q7
Q8
Q9
Q10
Q11
Q12
Q13
Q14
Q15
Q16
Q17
Q18
Q19
Q20
Q21
Q22
Q23
Q24
Q25
Q26
Q27
Q28
Q29
Q30
Q31
Q32
Q33
Q34
Q35
Q39
Q40
Q41
1560000841
1580000731
1580000800
1530003311
1590003230
1560001232
1560001241
1530003421
1530003311
1530003311
1530003311
1530002920
1530002920
1590001400
1590003290
1530002851
1560000541
1530002851
1560001360
1510000920
1510000920
1520000460
1590001190
1590003230
1590003290
1590003290
1590003430
1590003270
1510001080
1590001190
1590003020
1590003230
1560001360
1560001360
1530002060
1510000510
1590003290
S.FET
S.FET
S.FET
S.TR
S.TR
S.FET
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.FET
S.TR
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.FET
S.FET
S.TR
S.TR
S.TR
2SK1829 (TE85R,F)
3SK293 (TE85L,F)
3SK324UG-TL-E
2SC5107-O (TE85R,F)
UNR9113J-(TX)
RD07MVS2-T112
RD01MUS1-T113
2SC5110-O (TE85R,F)
2SC5107-O (TE85R,F)
2SC5107-O (TE85R,F)
2SC5107-O (TE85R,F)
2SC4226-T1 R25
2SC4226-T1 R25
XP1214 (TX)
UNR9213J-(TX)
2SC4116-BL (TE85R,F)
2SK880-Y (T5RICOM,F)
2SC4116-BL (TE85R,F)
2SK3019 TL
2SA1577 T106 Q
2SA1577 T106 Q
2SB1132 T100 R
XP6501-(TX) .AB
UNR9113J-(TX)
UNR9213J-(TX)
UNR9213J-(TX)
UNR911HJ-(TX)
UNR9210J-(TX)
2SA2048 TLR
XP6501-(TX) .AB
XP4216-(TX)
UNR9113J-(TX)
2SK3019 TL
2SK3019 TL
2SC4081 T106 R
2SA1576A T106R
UNR9213J-(TX)
T
B
B
B
T
T
T
T
T
B
T
T
T
B
B
T
B
T
T
T
T
T
T
T
T
T
B
B
T
T
T
T
T
T
B
B
B
75/39.5
77.8/37.9
66.2/37.9
51.4/23.1
71.7/19.1
82.6/27
76.1/27.6
70.7/34.4
59.4/36.3
56.8/36.4
59.1/31.6
54.1/32.3
54.1/34.8
56.5/32.6
59.1/32.6
55.5/44.1
51.5/39.2
43.3/29.9
27.7/29.4
71.9/16.4
24.9/25.9
81.1/15.1
76.5/15.1
75.7/11.7
49.6/18.4
24.8/16.7
63.8/10.8
36.1/9.4
91.9/8.5
91.4/5.2
16.5/23.5
19.9/22.5
11.6/31.9
9.5/30.5
39.1/42.7
39.1/40
59.7/11.9
D1
D2
D4
D5
D6
D8
D9
D10
D14
D15
D16
D17
D18
D19
D20
D21
D22
D23
D24
D26
D27
D28
D29
D30
1790001790
1750000581
1750000721
1750000581
1790001260
1750000721
1750000711
1750000711
1790001260
1790001260
1750000771
1750000771
1720000471
1750000771
1750000771
1750000721
1750000721
1790001250
1790001250
1790001790
1750000520
1790001260
1750000940
1790001260
S.DIO
S.DIO
S.VCP
S.DIO
S.DIO
S.VCP
S.VCP
S.VCP
S.DIO
S.DIO
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
RB876W TL
1SV307 (TPH3,F)
HVC375BTRF-E
1SV307 (TPH3,F)
MA2S077-(TX)
HVC375BTRF-E
HVC350BTRF-E
HVC350BTRF-E
MA2S077-(TX)
MA2S077-(TX)
HVC376BTRF-E
HVC376BTRF-E
1SV239 (TPH3,F)
HVC376BTRF-E
HVC376BTRF-E
HVC375BTRF-E
HVC375BTRF-E
MA2S111-(TX)
MA2S111-(TX)
RB876W TL
DAN222TL
MA2S077-(TX)
ISS400 TE61
MA2S077-(TX)
B
B
B
B
B
B
B
B
T
T
T
T
B
T
T
T
T
T
T
B
B
B
B
T
93.6/17.6
91.5/31.1
80.3/33.4
87.6/33.4
86.7/35.9
83/33.4
73.6/37.7
72.3/37.7
65.8/35.3
65.8/36.7
55.1/28.8
53.7/28.8
49.6/28.2
53.6/37.8
50.9/37.5
49.2/31.5
49.2/34.9
70.5/40.4
41.5/39.2
36.1/7.3
21.3/6.5
8.5/11.2
21.5/4.2
28.6/42.4
FI1
FI2
2030000150 S.MLH FL-335 (46.350 MHz)
2020001840 CER
ALFYM450F=K
B
62.7/27.1
X1
X2
X3
6070000191 S.DCR CDBKB450KCAY24-R0
6050011940 S.XTL CR-783 (15.3 MHz)
6050011720 S.XTL CR-764 (19.6608 MHz)
T
T
B
54.4/20
36.9/28.9
12/5.9
L1
L2
L3
L4
L5
L6
L7
L8
L9
6200012780
6200012470
6200012910
6200012470
6200012390
6200012470
6200007871
6200008090
6200008090
B
B
B
B
B
B
B
B
B
94.9/40.3
94.6/36.2
94.6/31.9
92.5/25.7
89.8/19.8
89.5/36.5
86.8/37.7
83.9/35.2
79.6/35.2
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
0.30-1.4-6TL 27.2N <COMO>
0.30-1.7-7TL 45.3N <COMO>
0.35-1.6-8TL 45.5N <COMO>
0.30-1.7-7TL 45.3N <COMO>
0.30-0.92-3TR 5.8N <COMO>
0.30-1.7-7TL 45.3N <COMO>
ELJRF 39NJFB
LQW2BHN68NJ03L
LQW2BHN68NJ03L
REF
NO.
PARTS
NO.
DESCRIPTION
H/V
M. LOCATION
L10
L11
L12
L13
L15
L16
L17
L18
L19
L20
L21
L22
L23
L24
L25
L26
L27
L28
L31
L32
L33
L35
L37
L38
L39
L42
L43
6200007750
6200007750
6200008090
6200007850
6200002861
6200012400
6200013100
6200005701
6200010401
6200003590
6200011031
6200011031
6200011031
6200003640
6200007760
6200008090
6200007170
6200007170
6200011021
6200007881
6200004480
6200003540
6200003640
6200008090
6200007720
6200007170
6200007170
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
LQW2BHN56NJ03L
LQW2BHN56NJ03L
LQW2BHN68NJ03L
ELJNC R82K-F
NLV25T-4R7J
0.30-0.91-4TL 8.6N <COMO>
0.45-1.5-5TL 18.3N <COMO>
ELJRE 22NGFA
ELJRE 39NJFA
EXCCL3225U1
ELJRF R10JFB
ELJRF R10JFB
ELJRF R10JFB
MLF1608E 100K-T
LQW2BHN82NJ03L
LQW2BHN68NJ03L
MLF1608A 3R3K-T
MLF1608A 3R3K-T
ELJRF 82NJFB
ELJRF 33NJFB
MLF1608D R82K-T
MLF1608D R22K-T
MLF1608E 100K-T
LQW2BHN68NJ03L
LQW2BHN33NJ03L
MLF1608A 3R3K-T
MLF1608A 3R3K-T
B
B
B
B
T
B
B
T
T
B
T
T
B
T
T
T
B
B
B
B
T
T
T
T
T
B
B
76.4/35
70.6/37.8
64/40.2
66.8/33.9
93.2/31.7
86.2/20.8
81.2/20.8
79/22.5
73/32.9
81.5/17.6
59.2/38.6
59.9/29.8
55.9/38.3
49.3/27.5
50.1/29.3
48.5/38
52.2/30.9
52.2/35.5
83.4/38.7
55.9/42.3
43.4/25.9
41.7/31.8
53.7/39.1
57.9/27.7
55.9/38
48.5/34.1
48.5/30.9
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
7030003540
7030005040
7030005530
7030005050
7030005050
7030005070
7030005310
7030005110
7030004980
7030005030
7030005090
7030005530
7030005090
7030005050
7030005310
7030008280
7030004970
7030005530
7030005090
7030008370
7030005090
7030005050
7030005090
7030005120
7030005080
7030005000
7030005000
7030005530
7030005590
7030005000
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
B
T
T
T
T
T
T
T
T
B
T
T
T
T
B
B
B
T
T
B
T
T
T
T
B
B
B
B
B
93.6/20.2
73.3/19.4
66.7/22.8
75.3/21.1
73.3/21.1
66.7/17.7
68/17.7
71.3/21.1
70.3/23.9
73.2/19.9
82.3/34.7
77.1/36.7
80.6/34.7
80.6/35.7
79.8/39
74.8/39.9
74.8/33.9
79.9/36.7
78.8/37.7
72.9/40.4
72.2/38.9
70.2/38.9
71.2/38.9
64.6/38
68/37.8
68.5/40.1
66/41.7
66/40.8
64.2/35.1
R31
R32
R33
7030007250 S.RES
7030010040 S.RES
7030007270 S.RES
B
B
B
67.7/35.7
64.2/32.1
66.1/31.1
R34
R35
R36
R37
R38
R39
R40
R42
R43
R44
R45
R46
R48
R50
R51
R52
R53
R54
R55
R57
R58
R59
R61
R62
R63
R65
R67
R68
R69
R70
R71
R72
R75
R76
7030008300
7030004980
7030008410
7030009140
7030005090
7030004970
7030005030
7030005240
7030005000
7030006610
7030005090
7030007290
7030005010
7030005050
7030003670
7030003350
7030007250
7030005090
7030005040
7030005590
7030005060
7030005040
7030005530
7030004980
7030005000
7030007290
7030004980
7030005050
7030005120
7030004980
7030005310
7030009320
7030005110
7030004980
ERJ3GEYJ 682 V (6.8 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 100 X (10 )
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 152 X (1.5 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 100 X (10 )
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 271 X (270 )
ERJ2GEJ 470 X (47 )
ERJ2GEJ 100 X (10 )
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 561 X (560 )
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 823 X (82 k)
ERJ2GEJ 471 X (470 )
ERJ2GEJ 471 X (470 )
ERJ2GEJ 100 X (10 )
ERJ2GEJ 680 X (68 )
ERJ2GEJ 471 X (470 )
[RUS-02], [RUS-05] only
ERJ2GEJ 220 X (22 )
ERJ2GEJ-JPW
ERJ2GEJ 151 X (150 )
[RUS-02], [RUS-05] only
ERJ2GEJ 184 X (180 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 392 X (3.9 k)
ERJ2GEJ 272 X (2.7 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 470 X (47 )
ERJ2GEJ 152 X (1.5 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 471 X (470 )
ERJ2GEJ 394 X (390 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 222 X (2.2 k)
ERJ2GEJ 681 X (680 )
ERJ2GEJ 103 X (10 k)
ERJ3GEYJ 823 V (82 k)
ERJ3GEYJ 181 V (180 )
ERJ2GEJ 220 X (22 )
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 680 X (68 )
ERJ2GEJ 333 X (33 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 100 X (10 )
ERJ2GEJ 101 X (100 )
ERJ2GEJ 471 X (470 )
ERJ2GEJ 222 X (2.2 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 4R7 X (4.7 )
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 101 X (100 )
B
B
B
T
T
T
B
B
B
B
B
B
B
B
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
T
T
B
B
55.7/24.8
52.5/25.2
50.5/25.2
52.5/15.5
50.7/16.3
46.5/21
55.8/22.3
56.2/21.1
51.8/15.4
47.5/15.4
54.8/15.4
52.8/13.7
53.8/13.7
51.5/25.2
66.3/38
97.3/41
93.1/34.9
80.2/22.9
81.5/21.8
79/20.8
74.3/23.9
72.3/23.9
71.3/23.9
71.4/36.2
68.7/32.3
68.1/35.2
68.7/33.9
65.6/34.1
65.6/33.1
61.4/36.1
57.7/39.3
58.1/38.6
59.9/34.4
58.6/37
57.7/38.3
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-1
[MAIN UNIT]
REF
NO.
R77
R78
R79
R80
R81
R82
R83
R84
R85
R86
R87
R88
R89
R90
R91
R92
R93
R94
R95
R96
R97
R98
R100
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R113
R115
R116
R117
R118
R121
R122
R123
R124
R125
R131
R132
R133
R134
R135
R136
R137
R138
R140
R141
R142
R143
R144
R145
R146
R147
R148
R149
R150
R151
R152
R153
R154
R155
R156
R157
R159
R160
R161
R162
R163
R164
R165
R166
R167
R168
R169
R170
R171
R172
R173
R174
R175
R176
R177
R178
R179
R180
R181
R182
R183
R184
R185
R186
R187
R190
R191
R192
R193
R194
[MAIN UNIT]
PARTS
NO.
7030004980
7030005310
7030008340
7030005050
7030010040
7030009320
7030008340
7030011000
7030011000
7030005090
7030008370
7030008370
7030005050
7030005110
7030005060
7030005090
7030005120
7030005100
7030005120
7030009270
7030008280
7030007290
7030005050
7030005120
7030005700
7030005160
7030005090
7030005100
7030005050
7030004970
7030005070
7030008300
7030005240
7030005090
7030005040
7030005120
7030007060
7030005040
7030005040
7030005110
7030008290
7030009290
7030005170
7030005230
7510001730
7030010080
7030005050
7030007290
7030005050
7030005040
7030005050
7030005040
7030010040
7030005000
7030005000
7030007340
7030005120
7030005090
7030005090
7030007350
7030005080
7030006610
7030008300
7030005030
7030005220
7030005220
7030005220
7030007300
7030005040
7030007290
7030008010
7030004980
7030005040
7030005290
7030005050
7030008410
7030008410
7030005240
7030009290
7030005000
7030005100
7030008010
7030005100
7030005700
7030005310
7030005090
7030005110
7030005310
7030005060
7030007270
7030005120
7030005160
7030005240
7030005090
7030006020
7030008250
7030005100
7030005310
7030005120
7030007280
7030008300
7030005720
7030005220
7030005220
DESCRIPTION
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.TMR
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 101 X (100 )
ERJ2GEJ 124 X (120 k)
RR0510P-182-D (1.8 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ-JPW
ERJ2GEJ 4R7 X (4.7 )
RR0510P-182-D (1.8 k)
RR0510P-392-D (3.9 k)
RR0510P-392-D (3.9 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 561 X (560 )
ERJ2GEJ 561 X (560 )
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 333 X (33 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 821 X (820 )
ERJ2GEJ 271 X (270 )
ERJ2GEJ 222 X (2.2 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 274 X (270 k)
ERJ2GEJ 105 X (1 M)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 470 X (47 )
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 184 X (180 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 684X (680 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 183 X (18 k)
ERJ2GEJ 562 X (5.6 k)
ERJ2GEJ 474 X (470 k)
ERJ2GEJ 334 X (330 k)
ERTJOEP 473J
ERJ2RHD 104 X (100 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 222 X (2.2 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ-JPW
ERJ2GEJ 471 X (470 )
ERJ2GEJ 471 X (470 )
ERJ2GEJ 153 X (15 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 393 X (39 k)
ERJ2GEJ 823 X (82 k)
ERJ2GEJ 394 X (390 k)
ERJ2GEJ 184 X (180 k)
ERJ2GEJ 152 X (1.5 k)
ERJ2GEJ 223 X (22 k)
ERJ2GEJ 223 X (22 k)
ERJ2GEJ 223 X (22 k)
ERJ2GEJ 332 X (3.3 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 222 X (2.2 k)
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 682 X (6.8 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 392 X (3.9 k)
ERJ2GEJ 392 X (3.9 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 562 X (5.6 k)
ERJ2GEJ 471 X (470 )
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 274 X (270 k)
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 333 X (33 k)
ERJ2GEJ 151 X (150 )
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 105 X (1 M)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 104 X (100 k)
RR0510P-682-D (6.8 k)
RR0510P-562-D (5.6 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 331 X (330 )
ERJ2GEJ 184 X (180 k)
ERJ2GEJ 563 X (56 k)
ERJ2GEJ 223 X (22 k)
ERJ2GEJ 223 X (22 k)
H/V
M. LOCATION
B
T
T
B
T
T
T
T
T
B
B
B
B
B
B
B
T
T
B
B
B
T
B
B
T
T
T
T
T
B
T
T
B
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
B
B
B
T
B
T
T
T
T
T
57.5/30.5
58.2/33.4
53.7/36.6
56.5/30.5
51.7/35.3
51.7/32.8
53.6/30.5
50.4/32.8
50.4/34.5
47.5/26.9
54.6/34.1
54.6/32.4
50.8/36.8
47.5/25.2
46.5/23.5
46.5/25.2
39.8/39.4
43.3/37.7
50.8/35.8
49.4/36.3
47/36.8
53.7/44
53.6/38.3
51.4/42.3
32.3/27.8
32.3/29.8
30.6/29.8
30.6/28.8
38.1/31.4
55.9/43.3
44.9/21
43.9/21
6.1/27.6
29.3/28.9
47/31.7
40.5/32
43.4/32.7
35.3/40.1
37/40.1
77.1/35.7
77.1/38.7
75.7/37.2
72.7/40.4
73.2/38.9
40.9/28.1
40.9/27.1
84.2/14.1
76.2/16.9
24.5/24
22.5/24
69.8/14.7
69.8/16.7
37.1/20.3
37.1/9.8
42.9/9.8
37.1/22.8
46.5/13.7
33.4/18.1
31.6/18.1
33.4/16.1
31.6/16.1
33.4/12.9
33.4/11.9
33.4/13.9
32.3/41.1
32.3/40.1
30.6/40.1
28.6/41.1
28.6/40.1
26.9/39.1
16/28.8
7.1/31.5
14.3/26.8
9/32.6
14.3/29.8
12.6/27.8
10/34.4
12.6/36.1
16/29.8
13/39.2
15.4/39.9
12.6/29.8
11.6/36.1
17.4/39.9
19.4/26.8
19.4/28.8
19.4/27.8
17.7/27.8
17.7/28.8
19.4/30.7
11.4/17
24.7/40.1
21.1/40.1
24.7/39.1
17.6/39.5
17.6/41.2
18.6/41.2
19.4/29.8
9.2/18.2
34.7/21.6
18/4.1
18/5.1
18/6.1
23.9/10.9
REF
NO.
PARTS
NO.
DESCRIPTION
R195
R196
R197
R198
R200
R201
R206
R207
R208
R209
R210
R211
R212
R213
R214
R215
R220
R221
R222
R222
7030005050
7030005240
7030005240
7030005240
7030005040
7030005240
7030005110
7030005090
7030005240
7030005220
7030008010
7030005070
7030005070
7030005070
7030005070
7030005070
7030004980
7030004980
7030005060
7030005220
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
VAR
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARY
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARY
S.RES
S.RES
S.ARY
S.RES
S.RES
S.RES
S.ARY
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 472 X (4.7 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 224 X (220 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 223 X (22 k)
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 101 X (100 )
ERJ2GEJ 333 X (33 k)
ERJ2GEJ 223 X (22 k)
[EUR-02] only
ERJ2GEJ 333 X (33 k)
ERJ2GEJ 471 X (470 )
ERJ2GEJ 101 X (100 )
TP76N00N-15F-A103-2251A
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 100 X (10 )
ERJ2GEJ 100 X (10 )
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 332 X (3.3 k)
ERJ2GEJ 332 X (3.3 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 334 X (330 k)
ERJ2GEJ 562 X (5.6 k)
EXB28V104JX
ERJ2GEJ 680 X (68 )
ERJ2GEJ-JPW
[2CH] only
ERJ2GEJ-JPW
[2CH] only
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 100 X (10 )
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 123 X (12 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 102 X (1 k)
EXB28V104JX
ERJ2GEJ 102 X (1 k)
ERJ2GEJ 104 X (100 k)
EXB28V102JX
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 473 X (47 k)
EXB28V102JX
ERJ2GEJ 153 X (15 k)
ERJ2GEJ 105 X (1 M)
ERJ2GEJ 105 X (1 M)
ERJ2GEJ 105 X (1 M)
ERJ2GEJ 683 X (68 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 331 X (330 )
ERJ2GEJ 152 X (1.5 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ 183 X (18 k)
ERJ2GEJ 273 X (27 k)
ERJ2GEJ 473 X (47 k)
ERJ2GEJ 101 X (100 )
ERJ2GEJ 101 X (100 )
ERJ2GEJ 562 X (5.6 k)
ERJ2GEJ 562 X (5.6 k)
ERJ2GEJ 103 X (10 k)
ERJ2GEJ 103 X (10 k)
ERJ3GEYJ 181 V (180 )
ERJ2GEJ 124 X (120 k)
ERJ2GEJ 154 X (150 k)
ERJ2GEJ 104 X (100 k)
ERJ2GEJ-JPW
R223
R224
R225
R226
R227
R228
R229
R230
R231
R232
R233
R234
R235
R236
R237
R238
R240
R241
R242
R251
R252
R254
R255
R256
R257
R258
R259
R260
R261
R262
R263
R264
R265
R266
R271
R272
R273
R274
R275
R276
R277
R278
R280
R284
R287
R288
R291
R292
R293
R294
R295
R301
R302
R303
R304
R305
R306
R307
R308
R309
R310
R312
7030005060
7030005000
7030004980
7210003061
7030005050
7030005120
7030005530
7030005530
7030005120
7030007300
7030007300
7030005100
7030005090
7030005230
7030009290
7410001140
7030005590
7030010040
7030010040
7030008010
7030005530
7030008010
7030008010
7030005050
7030005120
7410001140
7030005120
7030005090
7410001130
7030005090
7030005050
7030005240
7410001130
7030007340
7030005160
7030005160
7030005160
7030005070
7030005090
7030005090
7030005090
7030005090
7030005050
7030004980
7030007280
7030005030
7030005090
7030005090
7030008290
7030005600
7030005240
7030004980
7030004980
7030009290
7030009290
7030005050
7030005050
7030003350
7030005310
7030005100
7030005090
7030010040
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
4030017620
4030017410
4030017380
4030017650
4030017460
4030017460
4030017390
4030017640
4030017460
4030009990
4030007090
4030010000
4030011530
4030017460
4030017400
4030017630
4030017380
4030017460
4030017430
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EC1H100C
ECJ0EC1H240J
ECJ0EC1H050B
ECJ0EC1H270J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H180J
ECJ0EC1H150J
ECJ0EB1E102K
C1608 CH 1H 200J-T
C1608 CH 1H 470J-T
C1608 CH 1H 510J-T
C1608 CH 1H 110J-T
ECJ0EB1E102K
ECJ0EC1H220J
ECJ0EC1H120J
ECJ0EC1H050B
ECJ0EB1E102K
ECJ0EC1H101J
H/V
M. LOCATION
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
19.7/4.1
23.9/11.9
23.9/12.9
25.7/12.9
25.7/14.9
23.9/14.9
13.4/4.1
13.4/5.1
15.6/5.1
15.6/6.1
15.6/4.1
27.1/4.1
27.1/5.1
27.1/6.1
29/7.1
30.8/6.1
16.1/22.5
66.5/13.7
64.4/8.7
B
B
B
B
64.4/8.7
61.7/11.1
75.5/10.3
33.9/6.8
T
T
T
T
T
T
T
B
B
B
T
B
T
T
T
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
T
T
B
B
T
T
B
B
B
B
B
B
B
T
B
B
B
B
95/14
94.5/15.2
86.4/10.1
86.3/16.4
90.6/2.8
93.2/4.3
92.6/2.8
23/6.4
20.3/4.2
23/4.2
21.1/39.1
40.9/9.7
99.7/13.1
39.4/7.1
41.4/7.1
5.9/9.1
13.7/9.1
9.3/10.1
7.6/10.1
6/8.5
9/22.1
6.6/20.6
21.6/22.1
20.1/24.7
19.4/19.9
21.3/13.9
21.3/12.9
21.3/10.9
19.7/9.2
5.7/18.8
9.5/39.5
10.5/39.5
11.5/39.5
14.5/39.5
12.5/39.5
7.5/39.5
8.5/39.5
13.5/39.5
16.4/35.8
16/26.2
18.5/24.7
14.7/22.7
5.9/12.5
7.6/12.5
61.4/43.4
60.4/43.4
95.1/43.4
37.1/41.2
37.1/43.1
36.1/41.2
36.1/43.1
36.1/39.5
35.1/41.2
94.4/34.9
64.2/38.1
62.5/38.1
62.2/40.8
30.1/33.8
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
94.5/38.5
96.5/36.2
92.7/36.2
96.3/33.9
92.8/33.9
93.5/29.5
93.3/28.2
93.3/23.2
93.3/22.1
91.7/21.9
89.8/21.7
87.9/20.9
90.7/33.4
93.6/16
89.6/34.6
85.1/36.7
85.1/38.7
85.1/37.7
85.1/33.4
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-2
[MAIN UNIT]
REF
NO.
[MAIN UNIT]
PARTS
NO.
DESCRIPTION
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C36
C37
C38
C39
C40
C41
C42
C43
C44
C45
C46
C47
C48
C49
C50
C51
C52
C53
C54
C55
C56
C57
C58
C59
C60
C61
C62
4030017550
4030018860
4030017460
4030017580
4030017430
4030017460
4030017370
4030017370
4030016930
4030016930
4030017460
4030017420
4030017460
4030016790
4030017570
4030017460
4030017550
4030017580
4030017460
4030017460
4030017380
4030017460
4030017420
4030017460
4030016790
4030017630
4030017460
4030017460
4030017590
4030016790
4030017460
4030017570
4030017400
4030017460
4030017460
4030017460
4030016790
4030017430
4030017510
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C63
C64
C65
C66
C67
C68
C69
C70
C71
C72
C73
C74
C75
C76
C77
C78
C79
C80
C81
C82
C83
C84
C85
C86
C87
C88
C89
C90
C91
C92
C93
C94
C95
C96
C97
C99
C100
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C113
C114
C115
C116
C118
C119
C120
C121
C122
C123
C124
C126
C127
C129
C132
C133
4030017420
4030016790
4030017460
4030017460
4030017460
4030017430
4030017430
4030017430
4030016930
4030017460
4030017460
4030017460
4550006250
4030016930
4030017460
4030017460
4030016930
4030016930
4030017490
4030017460
4030017460
4030017730
4030017460
4030017430
4030017650
4030017460
4030016790
4030017460
4510008660
4030017430
4030017650
4030017420
4030017460
4030017460
4030017420
4030017460
4030017620
4030017460
4030017590
4030017360
4030017460
4030017460
4030017420
4030017460
4030016790
4030017460
4030017730
4030017460
4030017540
4030017660
4030017660
4030017460
4030017530
4030017460
4030017430
4030017390
4030017660
4030017510
4030017440
4030017660
4030017420
4030017340
4030016930
4030017400
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EC1H1R5B
ECJ0EB0J105K
ECJ0EB1E102K
ECJ0EC1H060C
ECJ0EC1H101J
ECJ0EB1E102K
ECJ0EC1H3R5B
ECJ0EC1H3R5B
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EC1H040B
ECJ0EB1E102K
ECJ0EC1H1R5B
ECJ0EC1H060C
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H050B
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EC1H120J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H070C
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EC1H040B
ECJ0EC1H220J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EC1H101J
ECJ0EC1H680J
[RUS-02], [RUS-05] only
ECJ0EC1H470J
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H101J
ECJ0EC1H101J
ECJ0EC1H101J
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
TEESVA 1A 106M8R
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1A104K
C1608 JB 1A 105K-T
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EC1H101J
ECJ0EC1H270J
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1E102K
EEE0JA220SR
ECJ0EC1H101J
ECJ0EC1H270J
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EC1H100C
ECJ0EB1E102K
ECJ0EC1H070C
ECJ0EC1H030B
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EC1HR75B
ECJ0EC1H330J
ECJ0EC1H330J
ECJ0EB1E102K
ECJ0EC1H0R5B
ECJ0EB1E102K
ECJ0EC1H101J
ECJ0EC1H180J
ECJ0EC1H330J
ECJ0EC1H680J
ECJ0EC1H221J
ECJ0EC1H330J
ECJ0EC1H470J
ECJ0EC1H010B
ECJ0EB1A104K
ECJ0EC1H220J
H/V
M. LOCATION
B
T
T
B
B
T
B
B
T
T
B
B
B
B
B
B
B
B
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
T
B
B
B
B
81.7/37.7
74.7/37.2
82.3/35.7
83.4/37.7
78.2/33.4
78.8/35.7
80/36.7
80/37.7
77.1/39.7
78.8/38.7
76.8/39.9
75.8/39.9
74.8/35.6
75.8/37.7
74.8/37.7
73.7/35.6
72.9/39.4
68.5/39.2
68.9/38.5
68.9/39.5
69/37.8
72.2/35.6
62.2/39
62.2/39.9
64.2/37.1
66/39.9
64.2/36.1
66.1/32.1
66.1/35.7
64.2/33.1
64.2/34.1
64.2/31.1
64.3/23.8
64.1/36.6
53.9/24.3
49.5/25.2
52.5/26.9
49.5/22.7
B
B
T
B
B
B
B
B
B
B
T
B
T
B
T
T
T
T
T
B
B
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
B
T
T
B
T
B
B
T
T
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
47.5/17.6
46.5/20.4
49.6/16.3
46.5/18.6
47.5/13.7
53.4/22.6
51.8/13.7
53.8/15.4
54.8/13.7
52.8/15.4
69.8/18.7
73.2/21.5
66.7/19.4
53.3/11.7
66.7/21.1
65.7/22.8
74.3/21.1
72.3/21.1
68/18.7
78.6/19.2
78.8/21.5
80.2/21.2
81.5/20.8
77.4/23.2
79.1/24.2
77.4/24.2
75.3/23.9
73.3/23.9
69.7/32.3
69.7/20.3
74.2/31.3
68.1/36.2
69.3/23.9
67.7/33.9
70.7/32.3
71.8/32.3
65.6/32.1
60.4/36.1
91.7/34.1
59.9/33.4
58.6/35.3
58.2/29.8
55/37
70.6/34.8
60.2/38.6
73.1/35.2
57.7/40.3
56.5/28.8
56.6/34.4
56.5/33.8
51.7/34.3
56.5/34.8
56.5/35.8
56.5/32.8
56.5/29.8
56.5/30.8
51.7/31.8
56.5/31.8
51.7/30.8
52.2/29.3
51.7/36.3
50/38.9
48/29.4
47.5/23.5
50.4/31.1
REF
NO.
C134
C135
C137
C138
C139
C140
C141
C143
C144
C145
C146
C147
C148
C149
C150
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
C169
C171
C172
C174
C175
C176
C182
C183
C184
C185
C186
C188
C190
C191
C192
C193
C194
C195
C200
C201
C202
C203
C205
C206
C207
C208
C209
C211
C213
C221
C222
C223
C224
C225
C226
C227
C228
C229
C230
C231
C232
C233
C234
C235
C236
C237
C238
C241
C242
C243
C244
C251
C252
C253
C254
C255
C256
C257
C258
C260
C261
C264
C265
C266
C269
C270
C271
C272
C273
C274
C275
PARTS
NO.
4030017390
4030017460
4030016790
4030017420
4030016930
4030016930
4030017460
4030017460
4030017460
4030017460
4550000270
4550004040
4550006250
4550000270
4030018860
4030016930
4030017420
4030017420
4030017420
4030017460
4030017460
4030017620
4030016930
4030017460
4030016930
4030017620
4030017500
4030017570
4030017590
4030016790
4030017360
4030016930
4030016930
4030016930
4030017460
4030017460
4030017530
4030017550
4030017640
4030017460
4030017620
4030017460
4030016930
4030016930
4030017460
4030017380
4030017570
4030017360
4030017360
4030017380
4030017570
4030017420
4030018860
4030016930
4030017460
4030017620
4030017630
4030017620
4030017630
4030017460
4030018860
4030016930
4030016930
4030016930
4030016930
4030016930
4030017460
4550005980
4030016790
4510008540
4030017460
4030016930
4030016790
4030017730
4030016790
4030017460
4030016790
4030017460
4510008660
4030017460
4030016930
4030016930
4030016790
4030017460
4030016970
4030017740
4030017740
4030016930
4030016950
4030016940
4030016930
4030017790
4030017730
4030016930
4510008540
4030017460
4030016930
4030017720
4030016950
4030016950
4030016950
4030016950
4030016950
4030016970
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EC1H180J
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EC1H470J
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
TEESVA 1E 474M8R
TEESVA 0J 685M8R
TEESVA 1A 106M8R
TEESVA 1E 474M8R
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EC1H470J
ECJ0EC1H470J
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H100C
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EC1H100C
ECJ0EC1H560J
ECJ0EC1H040B
ECJ0EC1H070C
ECJ0EB1C103K
ECJ0EC1H030B
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H0R5B
ECJ0EC1H1R5B
ECJ0EC1H150J
ECJ0EB1E102K
ECJ0EC1H100C
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EC1H050B
ECJ0EC1H040B
ECJ0EC1H030B
ECJ0EC1H030B
ECJ0EC1H050B
ECJ0EC1H040B
ECJ0EC1H470J
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EC1H100C
ECJ0EC1H120J
ECJ0EC1H100C
ECJ0EC1H120J
ECJ0EB1E102K
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
TEESVA 1A 475M8R
ECJ0EB1C103K
EEE1CA100SR
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1E471K
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1E102K
EEE0JA220SR
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1C223K
ECJ0EB1E821K
ECJ0EB1E821K
ECJ0EB1A104K
ECJ0EB1A473K
ECJ0EB1A393K
ECJ0EB1A104K
ECJ0EB1E682K
ECJ0EB1E471K
ECJ0EB1A104K
EEE1CA100SR
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1H331K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1C223K
H/V
M. LOCATION
T
B
T
B
B
T
B
B
T
T
B
B
T
B
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
B
B
B
T
B
B
B
B
T
T
T
T
T
B
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
T
T
T
B
B
T
B
B
B
B
B
B
T
T
T
T
T
T
B
T
T
T
T
B
T
T
T
T
B
T
T
T
T
T
B
B
B
T
T
T
T
T
T
T
50.4/36.1
51.4/43.3
57.3/44
52.8/32.7
57.5/28.8
43.3/35.9
53.6/39.3
51.4/41.3
42.9/21
44.9/22.7
50.5/32.3
49.2/39.8
50.3/43.7
47.1/39.8
43.9/22.7
43.3/39.4
35.3/41.1
37/41.1
37.8/39.1
44.3/37.7
39.5/32
38.1/32.4
36.1/31.4
36.1/32.4
6.6/28.9
43.4/33.8
43.9/28.1
42.5/27.6
43.9/27.1
43.4/31.7
43.2/24.7
55.8/23.3
56.5/19.8
56.5/18.6
91.7/35.7
85.7/18.9
92.5/19.1
94.5/33.9
94.8/30
65.2/39.3
66.5/39.3
80.6/37.7
40.9/30.1
77.1/37.7
47.5/20.4
51/38.9
52/38.9
53.6/27.1
55.3/27.1
51.2/27.5
52.2/27.5
27.2/27.3
28.2/27.3
47/30.7
47/29.7
55.9/39.3
55.9/40.3
55.9/41.3
54.2/42.3
54.2/43.3
32.3/26.8
30.6/27.8
26.8/31.6
18.9/33.7
29.7/9
40.9/29.1
83/11.6
81.2/13.5
86.9/13
89.4/15.7
85.7/17.9
85.7/16.9
74.4/13.3
76.2/13.3
24.5/23
24.2/27.8
69.8/15.7
69.8/17.7
76/15.5
78.5/16.9
35.3/9.8
44.7/9.8
40.5/9.8
46.5/15.4
33.4/17.1
29.9/16.1
33.4/14.9
33.4/10.9
34.5/12.1
30.6/41.1
32.3/39.1
30.6/39.1
28.6/39.1
26.9/40.1
69.7/15.5
64.8/12.4
63.4/8.7
11.6/37.8
14.3/28.8
14.3/27.8
9.5/28.8
12.6/28.8
10/32.6
11.6/34.4
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-3
[MAIN UNIT]
REF
NO.
PARTS
NO.
DESCRIPTION
H/V
M. LOCATION
C276
C277
C278
C279
C280
C281
C282
C283
C284
C285
C286
C287
C288
C289
C290
C291
C292
C293
C294
C295
C296
C297
C298
C299
C300
C304
C305
C306
C307
C308
C309
C310
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C335
C339
C340
C341
C342
C343
C344
C345
C346
C347
C348
C349
C350
4030016950
4030016930
4030017430
4030018910
4030018110
4030017780
4030017710
4030018900
4030016930
4030016930
4030017460
4550006250
4030017460
4030016930
4030017920
4030016780
4030016930
4030017740
4030016930
4030018110
4030018240
4030017710
4030018090
4030017510
4030017450
4030017460
4030017460
4030017460
4030017460
4030017460
4030017460
4030016930
4030017460
4030017420
4030017420
4030017460
4030017460
4030016930
4550007080
4030016930
4030016930
4030017730
4030017460
4030016950
4030016950
4030017420
4550006250
4510008900
4030018860
4030016930
4030016930
4030016930
4030017630
4030017580
4030017640
4030016930
4030016930
4030016790
4030016930
4030016930
4030017460
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EB1A473K
ECJ0EB1A104K
ECJ0EC1H101J
C1608 JB 0J 475K-T
ECJ0EB1H272K
ECJ0EB1E472K
ECJ0EC1H181J
ECJ0EB0J474K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
TEESVA 1A 106M8R
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1A683K
ECJ0EB1C153K
ECJ0EB1A104K
ECJ0EB1E821K
ECJ0EB1A104K
ECJ0EB1H272K
ECJ0EB1E562K
ECJ0EC1H181J
ECJ0EB1C822K
ECJ0EC1H680J
ECJ0EB1E271K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1A104K
TEESVA 1C 106M8R
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EC1H470J
TEESVA 1A 106M8R
EEEFC0J101P
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EC1H120J
ECJ0EC1H060C
ECJ0EC1H150J
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
T
T
T
T
T
T
T
T
T
T
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
B
T
B
B
T
B
T
B
B
B
T
T
T
B
T
T
T
B
T
T
T
T
B
B
B
B
B
B
B
B
B
B
T
T
T
T
12.6/34.4
12.6/37.8
16.4/39.9
36.8/21.6
21.1/27.8
17.7/26.8
17.7/29.8
19.4/31.7
22.9/39.1
22.9/40.1
16.6/41.2
22.1/40.7
18.6/39.5
19.5/30.2
27.5/16.1
25.7/10.9
25.7/13.9
25.7/11.9
23.9/13.9
29/5.1
29/6.1
27.1/7.1
30.8/7.1
30.8/5.1
18.4/39.9
57.7/11.4
11.3/24.3
61.7/12
61.7/10.2
75.7/9.8
75.5/11.3
21.3/11.9
65.4/8.7
74.5/6.1
33.9/7.8
86.6/3.3
93.2/5.9
91.6/2.8
93/11.3
90.4/10.1
89.6/3.7
88.6/3.7
19.3/4.2
94/14
88.1/10.1
85.2/14.1
89.4/17.6
87.8/8.9
54.6/22.6
5.9/17.2
9.3/12.5
5.9/10.1
18.3/4.2
5.6/4.2
7.6/9.1
11/11.2
11/10.1
8.9/6.3
6/10
21.3/14.9
59.4/43.4
J1
J2
J3
J4
J5
6510021901
6450001680
6450002250
6510018430
6510021901
S.CNR
CNR
CNR
S.CNR
S.CNR
BM02B-ASRS-TF (LF) (SN)
HSJ1122-010010
HSJ1456-010320
AXN330C038P
BM02B-ASRS-TF (LF) (SN)
[RUS-02], [RUS-05] only
T
86.6/6.8
B
11.8/30.6
T
50.4/11.7
F1
5210000830 S.FUS
ERBFE3R00U
T
98/14.8
DS1
5040002670 S.LED
CL-165HR/YG
T
102.8/12.4
MC1
7700002750 MIC
EM9745P-38-G <HOR>
S1
S2
S3
S4
2260002840
2260002800
2260002800
2250000490
SW
S.SW
S.SW
ECR
SKHLLFA010
SW-167 (SKQTLAE010)
SW-167 (SKQTLAE010)
TP70TF5163-15.9F-2775
[16CH] only
B
B
99.4/44.2
60.9/44.2
EP2
EP3
EP4
EP6
6910015600
6910015370
6910015370
6910015370
S.BEA
S.BEA
S.BEA
S.BEA
ACZ1005Y-241 (240)
ACZ1005Y-102-T
ACZ1005Y-102-T
ACZ1005Y-102-T
T
T
B
T
77.4/22.2
34.7/32
55.5/30.5
44.3/35.9
[CONNECT UNIT]
REF
NO.
PARTS
NO.
DESCRIPTION
C501
C502
4030017460 S.CER ECJ0EB1E102K
4030016930 S.CER ECJ0EB1A104K
J501
6910016390 CNR
H/V
M. LOCATION
T
T
8.3/5.3
9.3/5.3
IMSA-9230B-1-02Z145-PT1
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-4
• BC-160 (Optional)
[MAIN UNIT]
REF
NO.
ORDER
NO.
[MAIN UNIT]
DESCRIPTION
H/V
M. LOCATION
IC1
IC2
IC3
IC4
1110006480
1110003071
1140012301
1110002700
S.IC
S.IC
S.IC
S.IC
NJM2801U1-0543-TE1
uPC494GS-E1-A
uPD789112AMC-534-5A4-A
NJM2904M-TE1
B
B
B
B
10.2/62.3
13/36.7
19.1/19.6
35.1/13.8
Q1
Q2
Q3
Q4
Q5
Q6
1530002060
1550000090
1530002060
1530002060
1590000430
1530002060
S.TR
S.FET
S.TR
S.TR
S.TR
S.TR
2SC4081 T106 R
RSQ035P03TR
2SC4081 T106 R
2SC4081 T106 R
DTC144EUA T106
2SC4081 T106 R
B
B
B
B
B
B
37.3/63.9
37.3/60.9
35.8/19.3
41.6/18.3
23.7/26.6
22.5/58.2
D1
D2
D3
D4
D5
1730002350
1750000550
1750001110
1160000070
1750000550
S.ZEN
S.DIO
S.DIO
S.DIO
S.DIO
MA8110-M (TX)
1SS355 TE-17
SM240A-T
DAN202K T146
1SS355 TE-17
B
B
B
B
B
17.6/60.5
34.8/64.4
44.4/56
26.9/20.6
27.2/15
X1
6060000790 S.CER CSTCR4M91G
B
10.3/17.7
L1
L2
6190001640 S.COL SLF12555T-101M1R1
6200002611 S.COL NLV25T-R47J
B
B
35.3/52.7
20.8/28.2
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
R31
R32
R33
R34
R35
R36
R37
R38
R39
R40
R41
R42
R43
R44
R45
R46
R47
R48
R49
R50
R51
R52
R53
R54
R55
R56
R57
R58
R59
R60
R61
R62
R63
R64
R65
R66
R67
7030000460
7030003410
7030003200
7030009580
7030000540
7030000380
7030003520
7030003600
7030000740
7030000540
7030003560
7030003600
7030003770
7030003650
7030003770
7030003560
7030003410
7030003620
7030000560
7030000380
7030000440
7030000460
7030000260
7030000260
7030000500
7030007220
7030011200
7030011190
7030005871
7030003560
7030005341
7030000500
7030000740
7030003440
7030000460
7030005501
7030005671
7030000010
7030000010
7030000010
7030008240
7030000010
7030000010
7030000010
7030000010
7030000010
7030008240
7030000010
7030008240
7030000010
7030000010
7030008240
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030000010
7030003560
7030000100
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
20.3/58.6
37.3/65.8
34.6/61.1
31.8/73
30.1/26.8
30.1/29.6
39.5/18.4
13.8/30.5
25.8/34.9
24.8/37.8
10.8/30.5
19.3/34.5
21/34.5
21/40.3
19.3/40.3
22.7/40.3
8.6/43.5
16.7/42.1
28.1/40.4
26.3/28.6
24/11.4
24/8.8
20.3/11.4
20.3/8.8
30.5/22
30.2/19.6
30/18.1
26.9/16.6
40.4/15.1
29.8/15.9
43.4/11.1
31.7/9.8
42.1/14.4
40.4/12.2
34.7/23.8
33.6/21.3
30.1/25.1
28.1/42.2
27.7/8.4
34.6/9.2
38.9/7.4
30.1/33.3
28.1/33.3
29.1/38
29.1/36.1
43.9/18.3
43/28.9
23.5/5.7
34.1/38.2
23.9/34.9
24.7/32
38.6/33.1
34.4/33
32/60.1
42.1/41.5
37.2/41.5
24.9/57
27.6/49.3
16.3/58.3
4.9/31.7
39.1/41.5
31.4/43.6
40.1/38.7
4.9/49.5
8.2/13.6
10.2/45.1
C1
C2
C3
4030006900 S.CER C1608 JB 1H 103K-T
4030006900 S.CER C1608 JB 1H 103K-T
4030006860 S.CER C1608 JB 1H 102K-T
B
B
B
44.5/70.7
48.2/73.5
44.5/67.8
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
MCR10EZHJ 4.7 k
ERJ3GEYJ 561 V (560)
ERJ3GEYJ 100 V (10)
ERJ8RSJ R12V
MCR10EZHJ 22 k
MCR10EZHJ 1 k
ERJ3GEYJ 472 V (4.7 k)
ERJ3GEYJ 223 V (22 k)
MCR10EZHJ 1 M
MCR10EZHJ 22 k
ERJ3GEYJ 103 V (10 k)
ERJ3GEYJ 223 V (22 k)
ERJ3GEYJ 564 V (560 k)
ERJ3GEYJ 563 V (56 k)
ERJ3GEYJ 564 V (560 k)
ERJ3GEYJ 103 V (10 k)
ERJ3GEYJ 561 V (560)
ERJ3GEYJ 333 V (33 k)
MCR10EZHJ 33 k
MCR10EZHJ 1 k
MCR10EZHJ 3.3 k
MCR10EZHJ 4.7 k
MCR10EZHJ 100 (101)
MCR10EZHJ 100 (101)
MCR10EZHJ 10 k
ERA3YED 202V (2 k)
ERA3YEB 303V (30 k)
ERA3YEB 103V (10 k)
ERA3YKD 104V (100 k)
ERJ3GEYJ 103 V (10 k)
ERA3YED 332V (3.3 k)
MCR10EZHJ 10 k
MCR10EZHJ 1 M
ERJ3GEYJ 102 V (1 k)
MCR10EZHJ 4.7 k
ERA3YKD 124V (120 k)
ERA3YKD 393V (39 k)
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
ERJ12YJ0R00U
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
ERJ12YJ0R00U
MCR10EZHJ JPW
ERJ12YJ0R00U
MCR10EZHJ JPW
MCR10EZHJ JPW
ERJ12YJ0R00U
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
MCR10EZHJ JPW
ERJ3GEYJ 103 V (10 k)
MCR10EZHJ 4R7 (4.7)
REF
NO.
ORDER
NO.
DESCRIPTION
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21
C22
C23
C24
C25
C26
C27
C28
4030006900
4030006900
4510008540
4030011600
4030006900
4030011600
4510009150
4030006900
4030006900
4510009150
4510008660
4510008660
4030006860
4030011600
4030006900
4030006900
4030009980
4030011600
4030006900
4030006900
4030006900
4030004760
4030006900
4030006900
4030006900
S.CER
S.CER
S.ELE
S.CER
S.CER
S.CER
S.ELE
S.CER
S.CER
S.ELE
S.ELE
S.ELE
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
EEE1CA100SR
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1E 104K-T
EEE1EA470WP
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
EEE1EA470WP
EEE0JA220SR
EEE0JA220SR
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 152K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C2012 JF 1H 104Z-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
J1
6510024940 CNR
HEC2305-016250
DS1
5040002740 LED
RT3-03HRYG
H/V
M. LOCATION
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
32.9/69.7
32.9/71.1
17.5/63.8
13.4/60.8
9.2/58.7
13.4/63.8
43.6/62.8
35.8/67.9
32.4/67.9
26.5/62.8
34.3/28
40.8/23.8
12.3/30.5
19.3/37.4
21/37.4
13.1/42.2
8.6/42.1
9.5/21.9
19/25.5
26.9/23.2
26.9/18
33.2/17.5
41.9/11.1
29.5/12.6
30.1/23.7
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-5
SECTION 7.
MECHANICAL PARTS
[CHASSIS PARTS]
REF
NO.
ORDER
NO.
[ANT UNIT]
DESCRIPTION
QTY.
MP601
ORDER
NO.
DESCRIPTION
6910015910 ANT CONNECTOR 104
6910015860 IMSA-6277S-O2A-G
S1
2260002870 AS-243-A13
SP1
2510001061 K036NA500-67
1
W1
W2
8900009640 OPC-963
8900009640 OPC-963
1
1
J501
MP1
MP2
8010019695
8210020920
8210020930
8210024600
1
1
1
[ACCESSORIES]
MP4
MP5
MP6
MP7
MP8
MP9
MP10
MP11
MP13
MP14
MP16
MP17
MP20
MP21
MP22
MP23
MP24
MP25
MP26
MP27
MP28
MP29
MP30
MP31
MP32
MP33
MP34
MP35
MP36
MP37
MP42
MP43
8210020820
8210024560
8930063360
8930063370
8930040390
8930046050
8210020550
8930063351
8610011930
8610012130
8930075190
8930063340
8930063060
8930063400
8930063411
8930063420
8930043760
8930059360
8930070362
8610007510
8610007920
8830001720
8810009221
8810009561
8810009511
8810009511
8810009511
8810010430
8930051290
8930042350
8930056540
8830001701
8830001701
8830001741
8930074580
8930074610
[2CH] only
[2CH] only
2775 CHASSIS-5
2775 FRONT PANEL (Incl. MP3, 4, 5, 6, 7)
[16CH]
2775 FRONT PANEL (A) (Incl. MP3, 4, 5, 6, 7) [2CH]
2775 A-FRONT PANEL
(Incl. MP3, 4, 5, 6, 7, 43)
[F3018]
2775 PTT PANEL
[Others]
2775 A-PTT PANEL
[F3018]
2775 PTT BUTTON
2775 PTT RUBBER
SPEAKER NET (B)
SPEAKER NET (C)
2721 REAR PANEL
2775 LENS-1
KNOB N-318 (Incl. MP23)
KNOB N-323 (Incl. MP24)
[16CH] only
2775 C-MAIN SEAL
[16CH]
2775 A-MAIN SEAL
[2CH]
2721 T-RUBBER
2775 SIDE PLATE
2775 B-TOP PLATE-1
[16CH]
2775 A-TOP PLATE
[2CH]
1923 MIC SEAL
2600 RELEASE BUTTON
2775 RELEASE PLATE (A)-2
KNOB SPRING NO.7800
KNOB SPRING NO.1500
[16CH] only
2721 ANT NUT
SCREW BT B0 2X8 NI-ZK3 (BT)
SCREW BT B0 2X6 NI-ZK3 (BT)
SCREW BT B0 2X4 NI-ZC3 (BT)
SCREW BT B0 2X4 NI-ZC3 (BT)
SCREW BT B0 2X4 NI-ZC3 (BT)
SCREW TRUSS M3X5 SUS SSBC
2251 OPT SHEET
1922 MIC SHEET
PUSH SPRING (AH)
VR NUT (Q)-1
VR NUT (Q)-1
[16CH] only
VR NUT (S)-1
[2CH] only
2775 NAME SHEET
[F3018] only
SP NET (E)
[F3018] only
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
9
1
1
1
1
1
2
1
1
1
1
1
QTY.
8510016350 2721 ANT PLATE
J1
J2
MP3
1
1
REF
NO.
1
[CONNECT UNIT]
REF
NO.
REF
NO.
EP1**
EP2**
EP3**
EP4**
MP1**
MP2
MP3
MP4
ORDER
NO.
DESCRIPTION
QTY.
6910016390 IMSA-9230B-1-02Z145-PT1
ORDER
NO.
–
–
–
–
–
–
8210020560
8210022780
8810004861
8930051290
EP1
1
DESCRIPTION
FA-SC55V-2
BP-232N
BC-160
BC-145A
BC-145E
MB-94
2721 JACK PANEL
2927 JACK PANEL
SCREW PH M2X6 ZK3
2251 OPT SHEET
QTY.
[USA-03], [USA-04] only
[USA-03]
[USA-04]
[Others]
[F3018]
EP2
MP1
MP2
MP3
MP4
[MAIN UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
QTY.
J2
J3
6450001680 HSJ1122-010010
6450002250 HSJ1456-010320
1
1
MC1*
7700002750 EM9745P-38-G
1
S1
S4
2260002840 SKHLLFA010
2250000490 TP70TF5163 15.9F-2775
MP1*
MP2
MP3*
MP4*
8410002531
8510016460
8510016470
8510016580
2681 PA HEATSINK-1
2775 VCO COVER
2775 VCO CASE
2775 SHIELD PLATE
[16CH] only
1
1
1
1
1
1
*: Refer to “BOARD LAYOUTS.”
**: Optional product.
Screw abbreviations
A, B0, BT: Self-tapping PH: Pan head ZK: Black NI-ZU: Nickel-Zinc SUS: Stainless
7-1
1
1
1
1
1
1
1
1
2
1
IC-F14S/F15S/F16S
MP37(C)
MP13(C)
MP17(C)
J1(C)
MP36(C)
MP35(C)
MP8(C)
MP31(C)
MP1(C)
MP17(C)
ANT Unit
IC-F14S/F15S/F16S MP29(C)
MP30(C) CONNECT Unit
S1(C)
MP32(C)
W2(C)
S4(M)
R226(M)
MAIN Unit
MP25(C)
MP14(C)
MP28(C)
*MP11(C)
J2(C)
S1(M)
MP10(C)
MP4(M)
SP1(C)
MP28(C)
J2(M)
MP26(C)
MP9(C)
MP27(C)
MP28(C)
J3(M)
MP26(C)
MC1(M)
MP28(C)
W1(C)
MP28(C)
166 (6 17/32)
W2(C)
MP20(C)
MP33(C)
MP16(C)
IC-F14S/F15S
MP42(C)
MP28(C)
119.5 (4 23/32)
MP22(C)
119.5 (4 23/32)
MP34(C)
31 (1 7/32)
MP2(C)
*: IC-F14/F15/F16/F3018 only
12.5 (1/2)
18 (23/32)
MP21(C)
17.8 (11/16) 38 (1 1/2)
unit: mm (inch)
7-2
1.7 (1/16)
4.8 (3/16)
1.7 (1/16)
53 (2 3/32)
2 (3/32)
SECTION 8.
BOARD LAYOUTS
• MAIN UNIT
(TOP VIEW)
D17
C129
Q19
C124
R293
R21
R125
R22
R23
C183
C23
R123
C88
R57
C89
R58
C299
R206
R210
R191
R242
R241
R53
L18
R227
C322
R240
IC12
Q31
C314
SP1 (CHASSIS)
V0
G
-VRI
SP
R211
R195
DS1
R2
J1
SP+
SP−
R215
C295
1
C296
R212
Q30
MIC
R213
R192
C318
CL
R193
R208
2
R209
R207
MC1
C298
+5
R214
CLOCLI-
C297
C323
R229
C315
C242
R232
R142
C243
C316
R141
CH
5
C241
R265
F1
R233
C254
C319
C291
R231
R194
C308
R264
R149
R150
IC5
J5
C293
C232
G
R198
R196
C231
SP
R197
C310
SDEC
R263
R228
C320
R151
C324
C292
R137
R133
C294
Q24
R262
R230
C235
R36
IC8
C83
R4
C78
R5
C79
C325
C238
R134
Q21
Q25
C253
C84
-APCV
Q23
C236
FI2
R200
R52
C92
L15
L19
C97
C96
R9
R59
R8
C72
R7
R138
X1
R201
R307
Q9
R65
C90
C94
R3
R6
C64
Q27
R147
C349
R256
C347
Q6
C80
R55
FUSE
R148
C252
C348
IC14
C182
L21
X1
IC13
V5
Q12
C76
R190
Q33
R288
R259
R54
IC2
C251
C290
C86
EP2
Q26
R145
C87
C85
T2
R140
R146
C193
MP4
C279
NWC-
-UNLK
R266
-DET
MCIN-
R261
Q8
L38
C192
MP3
L33
R143
R258
C171
C166
R5V
C233
R11
L22
C74
R135
C104
R37
R136
Q32
C355
SCK
SO
C305
Q22
R260
R287
Q42
L24
C164
C24
R13
C101
C120
C119
R14
Q7
R132
C211
C99
C27
C108
R68
C77
R102
C122
R83
C195
C213
L25
C194
C234
C280
C145
R173
C123
R67
C184
R18
D16
C1 33
C121
C162
R38
R175
C281
R131
R108
R176
C224
X2
C150
C271
R161
C185
R103
R105
R109
R164
R104
Q20
C163
R174
Q13
D21
L35
R115
C156
C274
R162
EP3
C165
C144
R186
R177
R111
C282
R159
C201
R167
C270
C200
R163
R257
V30
R106
BAL-
V25
R170
C273
S5V
V20
C158
C107
C102
C118
R19
R12
8
C272
-LVIN
V15
C221
R178
-MCOT
KEYCDEC-
V10
C283
R116
C31
C186
9
VHF
B6158E
Q34
Q35
R294
C350
C137
C113
R78
C157
R122
R121
R63
C161
C159
D14
C115
R72
C30
Q1
R61
R62
D22
R71
L39
C116
R81
C93
C95
R82
Q10
C57
C114
C42
D15
R79
Q14
R94
EP6
IC4
C140
R171
R166
C276
C126
D23
C43
R50
R24
D19
D20
IC7
L37
C191
D24
7
C275
R98
R124
C154
C190
C257
C127
R153
C258
L26
R154
C260
C134
R156
R157
R85
C261
R182
R84
R180
C284
C151
R118
C285
C155
C300
C278
R172
R169
R117
R181
C277
C269
C153
T1
R165
C152
R93
V45
V40
R152
LV
V35
C256
IC10
Q17
VCO5
R155
R237
IC6
3
6
T5V
CPU5-
4
R168
C148
D30
H70
H75
H65
V40
V35
V30
V25
V0
VPP
CP4
RST
VDD
GND
CP8
CP7
R24
R25
R23
Q6
R29
D5
C23
C24
R52
R11
R37
C14
R41
IC4
Q3
L1
R54
R53
R57
Q2
R42
H25
H20
H10
H15
H15
R64
R30
Q4
R48
C10
R47
R35
C26
R32
H45
D3
R34
H40
R8
C15
DS1
(A SIDE)
C25
R33
R50
C11
R49
C27
R28
R27
C28
R26
R38
R6
R46
R39
R20
R45
R55
R63
R4
H35
R3
R40
R31
R36
H30
H0
H5
CP1
C13
C12
C4
C5
R5
R7
R56
C3
D4
H30
J1 (A SIDE)
R21
R44
R62
C1
CP3
Q5
R10
H25
V0
L2
R43
GND
IC3
CP5
R14
R22
R13
C18
C22
C17
R15
R17
R59
Q1
B-6209B
C19
R19
R16
R2
D2
TXD
C21
R67
CP2
R60
D1
C6
R9
H20
V10
V5
C16
CP6
H35
C8
R18
H40
V15
RXD
R65
R61
H45
H50
IC1
C7
X1
R51
V5
V10
R66
R58
V0
V15
R12
IC2
H55
C9
C2
H50
H10
H5
H0
8-1
V20
C20
H60
V20
V45
H15
C502
V50
H10
C501
H80
V10
H85
V55
H5
V5
H90
V60
• BC-160
(TOP VIEW)
B6160
BATT
H95
V65
H0
J501
V70
H100
V75
J2
MICG
• ANT UNIT
(TOP VIEW)
MIC
• CONNECT UNIT
(TOP VIEW)
CLOUT
AFOUT
SPG
J3
H10
H5
H0
• MAIN UNIT
(BOTTOM VIEW)
V45
S3
C132
R91
R
M
VCO5
1
R92
R220
T5C
M
+5
C62
T
UNLK
R187
C65
IC1
-S5V
-CPU5
C339
R179
R254
C223
Q29
C266
R222
C311
R252
R255
C341
C344
R251
R234
R225
X3
V5
C343
C342
C321
R235
R236
D29
J3
D27
D26
C313
C312
J2
R291
V10
C346
R238
R292
D28
C345
C307
C326
R226
IC15
C75
C304
C340
C255
S5V
C66
R144
V15
R43
R45
C68
C244
R42
R46
C71
R224
R223
C70
C317
C225
C306
Q28
Q41
C265
C309
R44
R221
C69
C226
IC9
C227
C264
V20
C63
C188
S5C-
-DAST
-VCC
DISC
-SO
R
SCK-
PTT
T5V
-BIAS
R284
V25
R90
R5V
-BAL
C168
C169
C237
V30
C160
R110
-TEMP
C61
Q4
MP1
V35
J4
R86
C59
R35
R48
R34
C91
L20
C228
V40
R276
R277
R271
R272
R273
R280
C289
C230
C15
R275
R278
R183
R274
R184
C288
C286
R185
L43
C60
C67
C229
-LVA
C58
C167
R40
C172
D1
R33
R39
R10
C81
C174
L5
REF-
C203
C335
L17
C73
L16
R1
C13
C12
C82
C11
C10
R160
-R5V
C202
D18
L4
C56
C9
R312
L42
C146
C110
FI1
C222
R113
L27
C139
EP4
R80
C7
MP1
-DUSE
-PLST
+5-
C176
C8
R305
R96
L28
R31
C55
R77
D2
C51
R32
C138
R88
Q16
R97
R95
R87
Q15
C53
L3
C105
C111
C54
L13
C287
-DET
R89
C103
R29
T5V
R306
R100
R303
L23
R304
R76
Q18
R301
C141
Q40
C205
R75
R69
C26
C206
R70
Q11
C100
D4
C109
C149
R309
C52
C106
D8
C20
C143
C147
L12
R25
C44
L11
R308
C50
R30
R101
C47
C46
Q3
C135
C208
C207
C48
C45
D5
R310
C41
D10
R17
C6
C14
C39
L10
C36
D6
C4
L2
C3
L9
C16
C175
C49
C28
L8
C5
D9
C29
C38
C22
C17
L6
R16
C25
C37
L31
C19
C33
C32
C18
Q2
L7
R26
C40
R15
C2
R20
C209
L32
R302
R51
R28
L1
R107
Q39
R295
R27
MIC
S2
V0
H5
H0
H10
H20
H15
H25
H30
H40
H35
H45
H50
H55
MC1
• CONNECT UNIT
(BOTTOM VIEW)
• ANT UNIT
(BOTTOM VIEW)
V10
V20
V5
V15
B6159B
V0
H5
H10
H15
V10
J1 (CHASSIS)
H0
V5
V0
S-14111IH-P2-w
Printed in Japan
© 2004−2008 Icom Inc.
H0
H5
H10
H60
H65
H70
H75
H80
H85
H90
H95
H100
• BC-160
(BOTTOM VIEW)
8-2
SECTION 9.
BLOCK DIAGRAM
S5V
Q17
2SC4116
Q18
2SK880
LVIN
15.3MHz
X2
CR-783
IC7
NJM12902
RIPPLE
FIL
BUFF
D22
HVC375B
VCO
SW
R5V
RX VCO
LV
ADJ
Q39:2SC4081
Q40:2SA1576
136-174MHz
MAIN UNIT
Q15:XP1214
Q16:UNR9213J
Q14 2SC4226
D19,20:HVC376B
Q12
2SC5107
Q10
2SC5107
BUFF
BUFF
D14,D15
MA2S077
Q7
RD07MVS1
Q8
RD01MUS1
Q9
2SC5110
D2:1SV307
D5:1SV307
D1
RB876W
BAL
REF
Q19
2SC4116
LOOP
FIL
CHARGE
PUMP
TCXO
BUFF
LV
Q20
2SK3019
PLL
IC
FM
MOD
ATT
BUFF
IC7
NJM12902
BUFF
FI1
FL-335
RSSI
182.35MHz-220.35MHz
1
Q3
3SK324
46.35MHz
IF IC
45.9MHz
IF
AMP
XTAL
BPF
BPF
BPF
LVA
MIXER
X1
CERAMIC
BPF
SQIN
GATE
CTRL
APC
AMP
Q6
UNR9113J
MUTE
SW
T2
D4
HVC375B
RF
AMP
Q2
3SK293
BPF
BPF
T2
TMUT
D8
HVC375B
T1
Q26
UNR9213J
FI2
NOIS
LPF
IC2
TA75S01F
D9
HVC350B
D10
HVC350B
IC1:TA31136FN
RSSI
ANT
SW
PWR
DET
D18
1SV239
Q4
2SC5107
BPF
PWR
AMP
DRIVE
AMP
Q1
2SK1829
Q11
2SC5107
Q13
2SC4226
D16,17:HVC376B
LPF
PRE
DRIVE
TX/RX
SW
TX VCO
LV
ADJ
FAST
SW
IC4
MB15A02
X3
D21
HVC375B
W/N
SW
CDBC450CX24
ALFYM450F=K
DET
450KHz
J2
LVA,T1,T2
MOD
IC6
NJM13403
Q34
2SK3019
OPTION CONNECTOR
MCOT
MCIN
IC10
CD4066
RMUT
RX
MUTE
HPF
IC6
NJM13403
HSJ1122-010010
Q35
2SK3019
MC1
HPF
D/A
MIC
MUTE
IC6
NJM13403
DET
DISC
OPTION CONNECTOR
MMUT
CTCSS/DTCS
Q28:UNR911HJ
ANALOG
SW
IC6
NJM13403
IC8
M62363FP
PTT
AMP
RMUT
PTT
DET
LPF
PTT
PTTI
OPTION CONNECTOR
TMUT
TONE
IC12
TA7368F
AF VOL
HSJ1456-010320
AF
AMP
SENC0-3
BEEP
IC5
NJM12902
LPF
J3
Q30:2SA2048
Q31:XP6501
J1
AFON
CTCSS/DTCS DEC
IC7
NJM12902
LPF
IC7
NJM12902
BM02B-ASRS-TF
R131
TEMP
AMP
Q29:UNR9210J
D26:RB876W
CDEC
CLONE
BUFF
IC5
NJM12902
SDEC
F1
CPU
VCC
IC5
NJM12902
F1
IC13
T5
REG
R5C
Q23:2SB1132
Q24:XP6501
Q25:UNR9113J
BEEPO
BUSY
MMUTE
DUSE
FIL
SW
T5V
Q22
2SA1577
S5C
S4
TP70TF5163
F2
VCC
SIGO
2
T5C
CENC0-2
LPF
Q27
UNR9213J
1
Q21
2SA1577
S5
REG
R5
REG
R5V
CH
SELECT
S5V
+5
REG
IC14
BD5242
IC15
BR24L16FV
RES
EEPROM
Explanatory notes
IC9
NJM2870
RESET
CONTROL LINE
COMMON LINE
RMUTE
TX LINE
CPU5
D28
MA2S077
AFONO
+5V
CSFT
SHIFT
SW
19.6608MHz
X3
CR-764
Q32:XP4216
G
LED
CTRL
DATA LINE
R
DS1
CL-165HR
9-1
RX LINE
BT1
LPF
OPTION
SP1
1
2
BATTERY_1
DET
PWR
CTRL
AFONO
SECTION 10.
VOLTAGE DIAGRAM
VCC
T5V
S5V
180
C3
C5
82K
R51
C176
24P
1.5P
15P
L1 27.2N
27P
180
R307
4.7U
0.001
C171
R52
0.001
C101
15P
C8
6.8K
C9
0.001
R1
0.5P
D1
LPF
45.3N C2
C4
10P
5P
R2
C91
22
47P
C94
10K
R50
10P
45.5N
L3
L2
C6
45.3N 0.001 1SV307 0.001 C175
RB876W
20P
C11
51P
C13
MP1
RD07MVS2
D2
C7
L4
47P
L15
0.001
C174
C82
C84
R53
C83
R54
470P
4.7K
100K
0.001
22
2681
100P
27P
C87
0.001
R55
C10
C15
18.3N
0.001
L17
C81
1
0.001
C172
EP2
22N
0.001
L18
C86
C89 68
C88
33K
0.01 R57
R59
R58
4.7K
C90
R62
0.001
C85
C97
47P
C96
100
C95
0.001
R65
470
1k
8.6N
Q7
J1(CHASSIS)
18P
47P
C106
0.001
10
39N
L19
100
R61
R68
10K
0.001
R67
C99
D15
5.8N
L5
C12
L16
C183
C111
XP1214
27P
MA2S077
R69
10P
C205
3
Q8
RD01MUS1
100P
Q9
2SC5110
C93
D14
2.2K
R63
C108
4.7
0.01
C107
0.001
R71
R72
0.1U
R70
R80
10K
UNR9213J
Q16
2
560
10P
EXCCL3225U
ACZ1005Y
L20
C92
MA2S077
C100
2SC5107
1
4
Q10
Q11
2SC5107
Q15
5
120K
L21
C109
R76
0.001
100
L23
0.001
C105
R75
7P
3P
C103
R78
L22
0.1U
C104
C113
2SC5107
0.5P
C120
C118
220K
0.1U
C110
R77
470P
100
0.1
EP4
C139
C116
0.001
0.75P
Q12
R88
C122
18P
R82
2SC4226
C102
0.001
C121
22P
HVC375B C133
D21
R86
1SV239
L38
0.001
120K
33P
4.7
33P
1P
C129
3.3U
D18
10U
100K
C193
D16
3P
R83
Q13
C123
68P
R87
1.8K TX VCO
C119
D22
R84
HVC376B HVC376B
L24
C192
D17
C194
3P
4P
47P
C138
33P
18P
HVC375B C134
3.9k
33N
L43
2SC4226
560
L39
C124 82N
0
0.001
100P
1
2
3
4
0.001
C203
D19
3.3U
C115 C114
2.2K
C148
10 MSVA
HVC376B HVC376B
L37
4P
D20
10U
0.01
C137
C190
L42
4.7K
C182
R24
1k
MA2S111
R4
R6
68K
C72
T2
C74
0.001
0.1
R7
C80
120K
T1
0.001
R3
C24
0.001
10K
C78
10K
R14
10K
R5
1
TA75S01F
2
0.001
TMUT
C76
Q6
UNR9113J
APC
4
100
1.5K
11P
C73
D5
45.3N
C14
1SV307
22P
C16
12P
39N
0.001
R10
L6
L7
C17
MA2S077
D6
82N 5P
L31 C18
68N
100P
L8
C20
6P
R9
0.001
C19
C25
220K
IC2
5
3
0.1
0.001
10
C77
C23
100K
100K
0.001
C27
R13
T2
RSSI
0.001
C42
D23
1
C26 100P
3.5P
68N
C28
L9
330K
5.6K
R125
R123
R121
220K
0.1
R19
100K
C31
C30
0.1
10
120K
270 R15
HVC375B
HVC375B C22
1.5PD8
D4
C79 0.1
R8
REF
LVA
T2
T1
BAL
SO
SCK
DAST
MOD
T5V
R11
R18
C184
10
R17
47
0.001
R16
560
C32
C33
D9
4P
C38
R20
0.001
R21
C39
100K
100K
R22
C29
0.001 47P
RF AMP
10K
0.001
D10
0.001
R23
C43
470K
3.5P
1.5P
56N
C45
5P
C44
L11
82K
R25
0.01
0.001
C48
68
R29
C50
NWC
R12
3SK293
C37
0.01
Q2
HVC350B
C40
2SK1829
AGC
Q1
R124
0.1
0.001
L10 56N
470
C36
470
R26
R28
R27
0.001
R310
R308
0
4P
C55
4
6
5
3
Q3
3SK324
0.01
Q26
UNR9213J
C49
HVC350B
6P
R122
18K
C186
10
12P
120K
47P
C47
68N
100K
C46
R30
150K
470
0.001
7P
C52
L12
MIX
C64
47P
R309
C41
22P
C56
2.7K
0.82U
0.001
0.001
L13
C53
0.01
IF AMP
C65
R32 C51
22
R31
C57
0.01
C54
C59
0.001
100
R35
C60
680
180K
R48
R34
FI1
FL-335
1
2
Q4 0.001 150
2SC5107
68P
NOIS
RSSI
C66
C58 R33
C62
470 C188
0.001
47P
R36
100K
3.9K
C75
R38
10 MSVA
C67
0.001
1
100K
100P
2SK3019
X1
C61
100P
0.001
C63
C69
C70
0.1
0.1
C71
R44
C68
100P
C169
100P
390K
0.82U
7P
L33
C164
56P
C335
1.5K
R40
0.01
C165
0.22U
L35
680K
10P
2SC4116
*3 MULTI
IF IC
IC1
MIXIN 16
OSCIN
GND 15
OSCOUT
N-REC 14
MIXOUT
N-DET 13
VCC
RSSI 12
IFIN
IFOUT 11
DEC
QUAD 10
FILOUT
FILIN
AFOUT 9
TA31136FNG
R43
R45
1
2
3
4
5
6
7
8
47K R42
0.1
CDBKB450KCAY24
47
0.001
R37
C167
R39
3P
FI2
ALFYM450F=K
2
1
0.1
C168
543
0.001
R5V
R46
2.2K
1
C162
4.7K
C200
68N
C145
0.001
68K
R108
C144
C185
0.1
1k
R116
100K
Q20
PLSW
C195
5P
820
R96
C146
0.47 SVA
0.47 SVA
C147
0.001
C206
12P
12P
1
0.1
R113
C202
R111
C201
R109
4P
Q19
C161
NJM12902V
C150
C163
MOD
3
3.3U
R79
T5V
68N
180K
C166
100
R302
5.6K
R304
R115
Q39
2SC4081
R306
LVA
L27
100
R301
5.6K
R303
33N
R5V
R305 2SA1576
Q40
10K
1
R85
Q14
33P
C126 R81
C127 L26
47P
1.8K RX VCO
3.9k
220P L25
10P
C207
10K
IC7
1k
VCO5
ACZ1005Y
2775
2SC4116 MP3
L32
S5V
2
0.1
3.3U
6.8 MSVA
0.001
8
7
6
5
4
3
2
1
C209
9
10
11
12
13
14
15
16
4.7K
47
C154C151
C153 47P
SO
PLST
C152 47P
47P
4.7K
R118
MA2S111 1k
MB15A02PFV1
CLOCK FIN
DATA
LD
LE
GND
FC
DO
NC
VCC
FOUT
VP
P
OSCOUT
B
OSCIN
IC4
R107
C208
R117
220K
R90
10K
R100
0.001
C149
0.1
C140
C155
R94
0.001
150K
R97
R93
270
SCK
L28
R95
PLL
D24
UNLK
5P
C191
R89
EP6 ACZ1005Y
S5V
100K
R92
R91
Q18
33K
C132
1k
C135
0.001
R101
CP1
C143
0.001
CP06S
C141
LVIN
0.1
R98
10K
2SK880
0.001
10K
C157
R106
NJM12902V
0.1
R105
150K
C213
100K
0.001
EP3
REF
X2
1 VCON
VCC 4
2 GND
OUT 3
CR-783
7
5
ACZ1005Y
1M
IC7
6
R104
REF
0.1
R103
10P
C156
270K
C158
C159
R102
BAL C211
1
Q17
100
VCC
T5V
+5V
T5V
ERTJ0EP473J
VCC
S5V
+5V
R131
R227
TP76N00N
0.1
C317
100K
R292
IC5
1
3
NJM12902V
R214
68K
100
100K
100K
R277
CP11
CP12
BEEPO
AFONO
VCC
+5V
*C304
100K
R260
1k
R261
R5C
T5C
S5C
DAST
1k
NWC
PLST
UNLK
XP4216
DS1
YG
R287 330
4
R288
2
5
1.5K
1
6
HR
CL-165HR
*C355
3
0.001
C339
0.1
47K
R294
18K
S3
27K
KEY
S2
IC15
A0 1
A1 2
A2 3
VSS 4
BR24L16FV
SW-167
VCC
WP
SCL
SDA
R295
8
7
6
5
C350
R293
100K
R262
R264
BEEP
CBI2
CBI3
SCK
SO
CBI0
CBI1
SCK
SI
SO
CIRQ
CCS
CP10
DISC
DET
J4
*Q42
ESCL
ESDA
DUSE
BUSY
AFON
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
ATX
TLED
1k
AXN330C038
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
R276
R278100K
R275
100K
R273 1M
R274 68K
R272 1M
R271 1M
15K
R266
IC13
R259
MCIN CF20
MCOT R284
PTT [PTTO]
PTTI
Q32
CENC0
CENC1
CENC2
SENC0
SENC1
SENC2
SENC3
68K
6
7
R215
68K
5
68P
2
R213
C299
68K
0.0082
R212
C298
68K
0.0056
R211
22K
180P
IC12
NC
POUT 10
VCC
PWGND 9
NC
PREGND 8
C324
VIN
PHASE 7
47P
RIPPLE
NF 6
10 C325
TA7368FG
R230
10 MSVA
47K
R209
C297
SENC3
100K
R208
C296
SENC2
C295
C323
R229
10 0.047
CF20
CP15
RLED
0.1
0.1
C341
0.1
C346
12K
D28
R254 CSFT
12K
0.1
R251
12K
C345
6P
C343
12P
MA2S077
R255
PLSW
NMI
SI
PTT
OPT2
OPT1
OPT3
TLED
RLED
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
HD6433687C73FPV
0.1
R252
10
CR-764
X3
C344
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
47K
R263
10K
TEMP
R265
12K
*R242
CBI0
CBI3
CBI2
R206
CBI1 SENC0
220K
R207
SENC1
CLO
CLI
OPV2
OPV1
1k
NOIS
R257
TMUT
MMUT
RMUT
CCS
CIRQ
LVIN
RSSI
KEY
SDEC
CDEC
64
63
62
61
60 REMO
59
58
57
56
55
54
53
52
51
50
49
RES
C348
CP14
BUSY
RES
Q33
SW-167
R256
C349
IC14
OUT 1
VDD 2
VSS 3
BD5242G
5 CD
4 NC
UNR9113J
R280 10K
OPT3
OPT2
OPT1
SIGO
NMI
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
0.01
10K
C347
R178
0.47
NJM13403V
150
5
C342
1M
R180
BATV
7
0.1
47K
C294
Q27
0.068
R201
47K
CF20
CPU5
IC6
R200
4.7K
NJM12902V
C290
47K
12
820P
R195
47K
IC5
14
13
R198
100K
R291
SIGO
CP16
6
C283
33K
180P
R177
100k
C282
120K
0.0047
0.0027
C280
R190
330
47K
100K
R187 1k
R182
R181
0.1
R176
220K
R258
OPV1
OPV2
DAST [OPV3]
RMUT
0.001
C288
5.6K
R179 1k
MMUT
TMUT
270P
C300
C269
330P
150K
R184
C285
100K
R175
C281
0.039
C256
C258
0.0068
0.1
0.1
470
0.1
C340
R141
R142
470
0.1
100K
0.01
C243
100K
R145
R146
820P
C252
C241
R149
180K
0.1
C242
0.1
C221
C254 R150
3.3K
R197
R196
C293
56K
R193
C292
22K
S5V
0.1
180K
R192
R210
1
2
3
4
5
C318
10
C289
120K
IC5
NJM12902V
DAN222
AFONO
1SS400
0.001
330K
100K
R236
D27
D29
R235
C321
470P
C319
3.3K
3.3K
0.1
C320
R232
AFON
150K
0.1
3
2
1k
R231
C316
1
Q31
XP6501
R233
4
5
6
C501
0.1
C502
0.001
R186
120K
R174
UNR9213J
R234
CONNECT BOARD
R173
4.7
DUSE
1
3
4
6
7
9
R228
0.001
C315
68
R240
CF20
CP13
J501
1
2
CP6
R194
22K
1k
10K
0.047
Q30
2SA2048TL
IMSA-9110B-02
CENC1
R191
R238
*R241
4 3
ERBFE3R00U
C279
15K
BIAS
0.1
CENC0
CENC2
4 3
VCC
R143
15P
CLO
CLI
1
2
1
2
3
4
5
6
7
+5V
IC10
I/O1
VDD 14
O/I1 CONT1 13
12
O/I2 CONT4 11
I/O2 I/O4
CONT2 O/I4 10
CONT3 O/I3 9
VSS
I/O3 8
CD4066BPWR
C284
10K
100
D26
*S4
2 C1 A1
B1
5 C2 A2
B2
8 C3 A3
B3
R226
D30
NJM13403V
BIAS
C291
C3100.1
BEEP
47K 0.1 BEEPO
R110C160
47P
0.001
47P
C313
C311
C312
Q29
UNR9210J
R225
C322
2
R155
MA2S077
8
10
NJM13403V
C287
R185
3.9K
R165
14
12
6.8K
R183
270K
100P
C278
IC6
9
C286
R168
MMUT
MCOT
MCIN
R237 5.6K
RB876W
0.001
C314
F1
0.1
390K
470
0.001
10 MSVA
13
0.047
C326
1
22K
22K
R172
R169 150K
0.1
C277
IC6
0.015
R159
12K
5.6K
6.8K
47K
R166
C276
C274
0.047
100
CP5
9
150K
100k
BM02B-ASRS-TF
22K
8
RMUT
*J5
1
2
10
2SK3019
Q34
+5V
HSJ1456-010320
J1
IC7
R153 R152
R171
R163
24
23
22
21
20
19
18
17
16
15
14
13
0
0.1
R154
DET
BIAS
J3
C251
0.022
C257
NJM12902V
10K
0.047
CF20
39K
2
R162
0.001
C309
0.001
C308
470
HSJ1122-010010
R147
82K
CF20
1
2SK3019
C272 Q35
CP2
C223
CP3
3
R167
R224
100K
C261
C260
470P
C275 0.022
J2
13
DET
NJM13403V
IC6
C270
3.9K
R164
*C305
DISC
R148
IC8
VIN8
VIN1
VOUT8
VOUT1
VOUT7
VOUT2
VIN7
VIN2
GND
VDD
RESET
LD
VDAREF
CLK
DO
DI
VIN6
VIN3
VOUT3
VOUT6
VOUT4
VOUT5
VIN4
VIN5
M62363FP
R140
R156
100
0.047 0.047 0.047
9
NJM12902V
12
0.0027
33K
0.001
R223
C306
C273
C271
0.001
0.047
C255
R170
1
2
3
4
5
6
7
8
9
10
11
12
S5V
C253
10
4.7K
R160
12K
C307
S1
SKHLLFA010
0.1
R132
C224
0.01
C227
0.1
C230
S5C
0.01
C231
0.1
C266
*R222
CF20
4.7K
*Q41
CDEC
PTT
1k
0.001
R144 C244
NJM13403V
820P
8
NJM12902V
SIGNAL
IC7
R157
2.2K 14
PTTI
100
CP4
0.1
0.001
C264
C265
R220
10
R161
EM9745P
MC1
IC5
1.5K
4 IC6
V+
GND
11
NJM12902V
R151
Q28
UNR911HJ
4 IC7
V+
GND
11
0.1
0.001
C226
C225
C228
0.001
C229
10
10K
4
470P
2.2K
C232
R134
NJM12902V
SDEC
0
+5V
4 IC5
V+
GND
11
TEMP
R221
100
VCC
+5V
R312
3
2
1
Q25
UNR9113J
R5C
ATX
5
6
10K
4.7K
C233
Q24
XP6501
0.01
10K
0.001
C234
R136
0.01
4.7K
C235
R135
2SA1577
Q22
R137
0.001
R138
T5C
R133
Q23
22 2SA1577
Q21
C236
C238
0.001
C237
S5V
IC9
1 CTRL VIN 5
2 GND
3 NB
VOUT 4
NJM28704.7 MSVA
2SB1132
C222
VCC
+5V
*; Refer to “PARTS LIST.”
10 - 1
DC
IN
J1
R3
560
R62
MCR10-JPW
GND
C13
47
C12
0.01
R63
MCR10-JPW
R20
33k
16
15
14
13
12
11
10
9
Q5
DTC144EU
C19
0.01
R44
MCR10-JPW
NO-INVIN
INVIN
REFOUT
OC
VCC
C2
E2
E1
R12 10k
R52
MCR10-JPW
MP2 (C)
R5
0.12
R50
ERJ12-JPW
1
1
Q4
2SC4081
NO-INVIN
INVIN
FB
DTC
CT
RT
GND
C1
R19
33k
1
2
3
4
5
6
7
8
C16 0.001
R21
1k
3.54V
R64
MCR10-JPW
MP4 (C)
CP7
G
11 - 1
R33
10k
R36
4.7k
R37
120k
R47
MCR10-JPW
R30
100k
DS1
RT3-03HRYG
Measurement condition
input DC.16V
rapid charging to BP-230
1 2 3 4
R26
10k
C23
0.01
R
IC4
NJM2904M
R27
2k
R32
3.3k
R38
39k
R25
100
8 7 6 5
CP5
C26 0.01
VDD
VPP
R28
30k
CP4
R34
1M
RESET
CP3
C28 0.01
R24
100
TXD
R31
10k
R35 1k
RXD
IC3
μPD789112AMC-534-5A4-A
30
RXD
P23
29
TXD
P24
28
P20
P25
27
P11
AVDD
26
P10
ANI0
25
VDD
ANI1
24
VSS
ANI2
23
X1
ANI3
22
AVSS
X2
21
IC0
IC0
20
IC0
P50
19
RESET
P51
18
P52
P03
17
P53
P02
16
P00
P01
C25
0.1
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
CP8
C27 0.01
R66
10k
D5
1SS355
L2
0.47μ
R29
10k
CP6
C24
0.01
R51
MCR10-JPW
R54
MCR10-JPW
MP3 (C)
C21
0.1
[EUR]
[UK]
R17
10k
IC2
μPC494GS-A
D4
DAN202K
Optional product Charger BC-145UK
R7
1k
Optional product Charger BC-145E
R8
4.7k
MAIN UNIT
R15
56k
R16
560k
R14
560k
R11
22k
R46
MCR10-JPW
QTY.
C18
0.01
C17
0.1
C20
0.0015
DS1 (M)
DESCRIPTION
C11
0.01
C7 0.1
C8 0.01
C6 10
R13
22k
R43
MCR10-JPW
C14
22
EP1
Q3
2SC4081
R18
560
[ACCESSORIES]
ORDER
NO.
D1
MA8110
J1 (M)
3
R6
22k
REF
NO.
D3
SM240A-T
8.4V
C22
0.01
2830 TERMINAL
16.0V
R40
MCR10-JPW
1
R9
22k
8930064410
VSENS
R58
MCR10-JPW
R39
MCR10-JPW
R10
1M
LED RT3-03HRYG
MP1 (M)
MP1
IC1
NJM2801U1-0543-TE1
5
1
VO VIN
2
GND
3
4
CD VOR
R23
4.7k
5040002740
1
R59
MCR10-JPW
MP1 (C)
DS1
6
Q1
2SC4081
9.6uS
C10
47
1
R45
MCR10-JPW
Connector HEC2305-01-250
2
CHARGE
10.05V
QTY.
R22
3.3k
6510023070
DESCRIPTION
5.00V
R60
MCR10-JPW
R49
MCR10-JPW
J1
ORDER
NO.
5
L1
100μ
R4
10
R2
4.7k
[MAIN UNIT]
REF.
NO.
3
C9
0.1
1
1
2
1
C5
0.01
2830 case
2830 cover
Leg cushion (A)
Screw PH BT M3 × 6 NI-ZU
4
Q6
2SC4081
QTY.
C15
22
8010019750
8110008220
8930039620
8810008630
DESCRIPTION
C4
0.01
ORDER
NO.
R41
MCR10-JPW
MP1
MP2
MP3
MP4
CP1
CP2
D2
1SS355
C2
0.01
REF.
NO.
C1
0.01
[CHASSIS PARTS]
R55
MCR10-JPW
Q2
RSQ035P03TR
R57
MCR10-JPW
R56
MCR10-JPW
BC-160 (Optional)
C3
0.001
SECTION 11.
X1
CSTCR4M91G
4Vp-p
4.945MHz
R42
ERJ12-JPW
R48
ERJ12-JPW
R53
ERJ12-JPW
R61
MCR10-JPW
R65
MCR10-JPW
R67
4.7
to
battery
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : +81 (06) 6793 5302
Fax
: +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
<Corporate Headquar ters>
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : +1 (425) 454-8155
Fax : +1 (425) 454-1509
URL : http://www.icomamerica.com
E-mail : [email protected]
<Customer Ser vice>
Phone : +1 (425) 454-7619
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : +1 (604) 952-4266
Fax : +1 (604) 952-0090
URL : http://www.icomcanada.com
E-mail : [email protected]
Unit 1 / 103 Garden Road, Clayton VIC 3168 Australia
Phone : +61 (03) 9549-7500
Fax : +61 (03) 9549-7505
URL : http://www.icom.net.au
E-mail : [email protected]
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : +64 (09) 274 4062
URL : http://www.icom.co.nz
E-mail : [email protected]
Fax : +64 (09) 274 4708
10C07, Long silver Mansion, No.88, Yong Ding
Road, Haidian Dist rict, Beijing, 100039, China
Phone : +86 (010) 5889 5391/5392/5393
Fax
: +86 (010) 5889 5395
E-mail : [email protected]
URL : http://www.bjicom.com
Communication Equipment
Himmelgeister Str. 100, D-40225 Dusseldorf, Germany
Phone : +49 (0211) 346047
Fax : +49 (0211) 333639
URL : http://www.icomeurope.com
E-mail : [email protected]
Ctra. Rubi, No. 88 Bajos A 08174, Sant Cugat del Valles, Barcelona, Spain
Phone : +34 (93) 590 26 70
Fax : +34 (93) 589 04 46
URL : http://www.icomspain.com
E-mail : [email protected]
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : +44 (01227) 741741
Fax : +44 (01227) 741742
URL : http://www.icomuk.co.uk
E-mail : [email protected]
Zac de la Plaine
1 Rue Brindejonc des Moulinais BP 5804
31505 Toulouse Cedex, France
Phone : +33 (5) 61 36 03 03
Fax : +33 (5) 61 36 03 00
URL : http://www.icom-france.com
E-mail : [email protected]
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : +886 (02) 2559 1899
Fax : +886 (02) 2559 1874
URL : http://www.asia-icom.com
E-mail : [email protected]
81-850 Sopot, ul. 3 Maja 54, Poland
Phone : +48 (58) 550 7135
Fax : +48 (58) 551 0484
E-mail : [email protected]
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-14111IZ-C1-w
© 2004–2008 Icom Inc.

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download IC-F14/F15/F16/S IC-F3018 SERVICE MANUAL - R