Download Service Manual - Manuales de Service

DVD Portable Player
PET1002/PET1008
All version
Service Manual
TABLE OF CONTENTS
Chapter
Technical Specification……………………………………… 1
Safety Instructions…………………………………………… 2
Instruction for Use………………………………………………3
Mechanical Instructions……………………………………… 4
Troubleshooting & Service Tips…………………………… 5
Overall Block Diagram………………………………………… 6
Overall Wiring Diagram……………………………………… 7
Electrical Diagram……………………………………………… 8
Component Layout…………………………………………….. 9
Exploded View Diagram & Service Part List……………….10
Revision List……………………………………………………. 11
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
OSD
TEST
All
rights
reserved. No part of this publication may by reproduced, stored in a
CONFIGURATION
SETUP
retrieval
system or transmitted,
in any form or by any means, electronics,
mechanical, photocopying, or otherwise without the prior permission of Philips
3141 785 30824
Version 1.4
1.0 TECHNICAL SPECIFICATION
General
Dimensions (WxLxH):
Audio CD:
Weight:
Power supply:
Power consumption:
Operating temp. range:
Laser wavelength:
Video system:
26 x 18 x 3.0 cm
10.2 x 7 x 1.2 inches
1.13 kg / 2.48 lb
DC 9V 2.2A
30W
0 - 50˚C (32 ~ 122˚F)
650nm
NTSC / PAL / AUTO
Frequency response:
20Hz ~ 20KHz ± 1dB
Signal/noise ratio:
Audio distortion + noise:
85dB
-80(1KHz)
Channel separation:
Dynamic range:
85dB
80dB
Output
Audio out (analog audio):
Output level: 2V ± 10%
Load impedance:
10K
Video out Output level:
1Vp - p ± 20%
Load impedance:
75
Current consumption
DC-IN SUPPLY (9.0V)
Battery Charging Current
1.2A typ.
BATT. SUPPLY (7.2V)
Power Off
0A
Playback with TFT on
<1.2A typ.
Playback without TFT on
<600mA
Battery playtime
>2.5hrs
Headphone out (headphone output load 2x16ohm)
Maximum output power:
Frequency response:
SNR (A-wght):
THD (1kHz):
Left-Right Channel
Separation:
Left-Right Channel
Balance:
Supported disc type
DVD video discs:
Video CD:
>10mW
20Hz - 20kHz
80dB typ.
<1%
32dB typ.
1dB
DivX video discs:
In addition, this unit can play DVD+R & DVD+RW and CD-R &
CD-RW that contains audio titles or MP3 or JPEG files.
You cannot play disc other than the above listed.
(CVD, CD-ROM, CD-Extra, CD-G and CD-I discs cannot be
played on this DVD player)
Software upgrades
For the best performance of your DVD Portable. Check
www.philips.com/support for latest software
upgrades available.
To check the software version of your DVD Portable.
1. Press the SETUP key to enter the setup menu.
2. Press RETURN and then press 1. 2 and 3 on the
remote control.
3. The display will show the software version as the
date of which the software was built on the bottom
of the screen. E.g. 050303
Procedure on how to upgrade the software of the DVD
Portable
1. Download the latest software from the Philips
support site.
2. Unzipped the files and then burn it onto a CD ROM
then playback the CD ROM on the DVD Portable.
Pixel specification
<= 3 (max. 0 bright dots and 3 dark dots)
2.0 SAFTETY INSTRUCTIONS
GB
NL
ESD
WARNING
Alle IC’s en vele andere halfgeleiders zijn
gevoelig voor electrostatische ontladingen
(ESD).
Onzorgvuldig behandelen tijdens reparatie kan
de levensduur drastisch doen verminderen.
Zorg ervoor dat u tijdens reparatie via een
polsband met weerstand verbonden bent met
hetzelfde potentiaal als de massa van het
apparaat.
Houd componenten en hulpmiddelen ook op
ditzelfde potentiaal.
All ICs and many other semi-conductors are
susceptible to electrostatic discharges (ESD).
Careless handling during repair can reduce life
drastically.
When repairing, make sure that you are
connected with the same potential as the mass
of the set via a wrist wrap with resistance.
Keep components and tools also at this
potential.
F
WAARSCHUWING
ATTENTION
I
Tous les IC et beaucoup d’autres
semi-conducteurs sont sensibles aux
décharges statiques (ESD).
Leur longévité pourrait être considérablement
écourtée par le fait qu’aucune précaution n’est
prise à leur manipulation.
Lors de réparations, s’assurer de bien être relié
au même potentiel que la masse de l’appareil et
enfiler le bracelet serti d’une résistance de
sécurité.
Veiller à ce que les composants ainsi que les
outils que l’on utilise soient également à ce
potentiel.
D
AVVERTIMENTO
WARNUNG
Alle ICs und viele andere Halbleiter sind
empfindlich gegenüber elektrostatischen
Entladungen (ESD).
Unsorgfältige Behandlung im Reparaturfall kan
die Lebensdauer drastisch reduzieren.
Veranlassen Sie, dass Sie im Reparaturfall über
ein Pulsarmband mit Widerstand verbunden
sind mit dem gleichen Potential wie die Masse
des Gerätes.
Bauteile und Hilfsmittel auch auf dieses gleiche
Potential halten.
Tutti IC e parecchi semi-conduttori sono
sensibili alle scariche statiche (ESD).
La loro longevità potrebbe essere fortemente
ridatta in caso di non osservazione della più
grande cauzione alla loro manipolazione.
Durante le riparazioni occorre quindi essere
collegato allo stesso potenziale che quello della
massa dell’apparecchio tramite un braccialetto
a resistenza.
Assicurarsi che i componenti e anche gli utensili
con quali si lavora siano anche a questo
potenziale.
GB
Safety regulations require that the set be restored to its original
condition and that parts which are identical with those specified,
be used.
“Pour votre sécurité, ces documents
doivent être utilisés par des spécialistes agréés, seuls habilités à réparer
votre appareil en panne”.
NL
Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie in
zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,
identiek aan de gespecificeerde, worden toegepast.
CLASS 1
LASER PRODUCT
3122 110 03420
F
Les normes de sécurité exigent que l’appareil soit remis à l’état
d’origine et que soient utiliséés les piéces de rechange identiques
à celles spécifiées.
GB
Warning !
Invisible laser radiation when open.
Avoid direct exposure to beam.
D
Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu
beachten. Der Original zustand des Geräts darf nicht verändert werden;
für Reparaturen sind Original-Ersatzteile zu verwenden.
S
Varning !
Osynlig laserstrålning när apparaten är öppnad och spärren
är urkopplad. Betrakta ej strålen.
SF Varoitus !
I
Le norme di sicurezza esigono che l’apparecchio venga rimesso
nelle condizioni originali e che siano utilizzati i pezzi di ricambio
identici a quelli specificati.
Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina
näkymättömälle laserisäteilylle. Älä katso säteeseen!
DK Advarse !
"After servicing and before returning set to customer perform a
leakage current measurement test from all exposed metal parts to
earth ground to assure no shock hazard exist. The leakage current
must not exceed 0.5mA."
Usynlig laserstråling ved åbning når sikkerhedsafbrydere er
ude af funktion. Undgå udsaettelse for stråling.
2.1 ESD PROTECTION
Whenthepowersupplyisbeingturnedon,youmaynotremovethislasercautionslabel.Ifitremoves,radiationoflaser
maybereceived.
PREPARATIONOFSERVICING
PickupHeadconsistsofalaserdiodethatisverysusceptibletoexternalstaticelectrocity.
Althoughitoperatesproperlyafterreplacement,ifitwassubjecttoelectrostaticdischargeduringreplacement,
itslifemightbeshortened.Whenreplacing,useaconductivemat,solderingironwithgroundwire,etc.to
protectthelaserdiodeformdamagebystaticelectricity.
Andalso,theLSIandICaresameasabove.
Groundconductive
wriststrapforbody.
Solderingiron
withgroundwire
orceramictype
1M
Conductivemat
Thegroundresistance
betweenthegroundline
andthegroundislessthan10
SAFTY NOTICE
SAFTY PRECAUTIONS
LEAKAGE CURRENT CHECK
Plug the AC line cord directly into a 120V AC outlet (do
not use an isolation transformer for this check). Use an
AC voltmeter, having 5000 per volt or more sensitivity.
Connect a 1500 10W resistor,paralleled by a 0.15uF
150V AC capacitor between a knomn good earth ground
(water pipe, conduit, etc.) and all exposed metal parts of
cabinet (antennas, handle bracket, metal cabinet
screwheads, metal overlays, control shafts, etc.).
Measure the AC voltage across the 1500 resistor.
The test must be conducted with the AC switch on and
then repeated with the AC switch off. The AC voltage
indicated by the meter may not exceed 0.3V.A reading
exceeding 0.3V indicates that a dangerous potential
exists, the fault must be located and corrected.
Repeat the above test with the DVD VIDEO PLAYER
power plug reversed.
NEVER RETURN A DVD VIDEO PLAYER TO THE
CUSTOMER WITHOUT TAKING NECESSARY
CORRECTIVE ACTION.
READING SHOULD NOT EXCEED 0.3V
AC VOLTMETER
DVD VIDEO PLAYER
(5000 per volt
or more sensitivity)
1500
10W
AC OUTLET
Good earth ground
such as a water pipe,
conduit, etc.
0.15uF 150V AC
Test all exposed metal.
Voltmeter Hook-up for Leakage Current Check
The lightning flash with arrowhead symbol, within an
equilateral triangle, is intended to alert the user to the
presence of uninsulated "dangerous voltage" within the
product's enclosure that may be of sufficient magnitude to
constitute a risk of electric shock to persons.
The exclamation point within an equilateral triangle is
intended to alert the user to the presence of important
operating and maintenance (servicing) instructions in the
literature accompanying the appliance.
3.0 INSTRUCTIONS FOR USE
1 ,,, Up / down / left / right cursor
OK
Confirms selection
2 OSD
On Screen Display on / off
MENU
Displays MENU page
VIDEO OUT
Selection video format
4 OPEN
Opens disc door to insert or
remove disc
5 POWER/CHG
Power and charging indicator
IR
Remote sensor
6 ON . POWER . OFF
Switches the player on / off
- COMPONENT OUT(YPBPR)
- COMPONENT OUT(YCBCR)
- A/V or S-VIDEO OUT
- A/V IN (AUX)
7
MONITOR
Selection display
8 VOLUME
Volume control
Headphones jack
To adjust the brightness with
To adjust the color with 9 A/V OUT
Audio/video output jack
To adjust the screen of 16:9
or 4:3 with 10 A/V IN
Audio/video input jack
SOUND
Virtual surround sound on / off
DVD PLAYER LAYOUT
11 DIGITAL AUDIO OUT
Digital Audio output jack
3 Pause playback
12 S-VIDEO OUT
S-Video output jack
Starts / resumes playback
13 COMPONENT VIDEO
Press twice to stop playback
Component video output jack
/
For previous () or next ()
14 DC IN 9V
chapters, tracks or titles
Power supply socket
/
Search backward () or search
forward ()
Main unit controls
Front of player
Left of player
CAUTION
Use of controls or adjustments or performance of
procedures other than herein may result in hazardous
radiation exposure or other unsafe operation.
Right of player
Remote Control
1 ,,
,
Up / down / left / right cursor
OK
Confirms selection
2 VOLUME
Volume control
3 /
For previous () or next ()
chapters, tracks or titles
Pause playback
Starts / resumes playback
Press twice to stop playback
/
Search backward () or search
forward ()
4 OSD
On Screen Display on / off
Slow motion
5 AUDIO
Audio langauge selector
ZOOM
Enlarges video image
6 A>B
To repeat or loop a sequence
in a title
PLAY-MODE
Selects play order options
7 0-9
Numeric keypad
8 MUTE
Muting play volume
REPEAT
Repeats chapter / title / disc
9 RETURN
For VCD menu page
ANGLE
Selects DVD camera angle
10 SUBTITLE
Subtitle language selector
LANGUAGE
Language selector
11 MENU
Displays MENU page
12 SETUP
Enters SETUP menu
13 INFRA RED PORT
14 BATTERY COMPARTMENT
4.0 MECHNICAL INSTRUCTIONS
1. Back View as Fig.1
Remove 12 screws to remove base
5. Remove top cover as Fig.6
remove
screws
12 screws
remove
screws
remove
screws
Fig.1
2. Soldered short pattern for laser diode as Fig.2
Fig.6
6. Remove IF board and HV board as Fig.7
soldered
6 screws
Fig.2
3. Remove DVD driver and main board as Fig.3,4
Broken connection of DVD driver and main board
Fig.7
7. Remove LCD TFT as Fig.8
Remove serew to remove LCD TFT as Fig.8
Fig.3
Remove DVD driver and main board
Fig.4
4. Remove key board and other parts as Fig.5
Fig.5
Fig.8
5.0 TROUBLESHOOTING & SERVICE TIPS
Procedure to change regioncode
1.
2.
3.
4.
5.
6.
7.
Power on player and open DVD Door.
Press <Set Up> at Remote Control. In <Set Up Menu> select <Preferences> then press <OK>.
For PET1002 - Press successively 2 1 2 2 2 5. . .
Display will show <Region Code 2> for Europe:
Press key to input preference region code (see below table).
Switch off and re-switch on the product.
Verify Region code change done.
Region Code
1
2
3
4
5
6
Region
USA
EUROPE
ASIA PACIFIC
AUSTRALIA,
NEW ZEALAND,
LATAM
RUSSIA, INDIA
CHINA
REMARKS:
1. Password is CONFIDENTIAL.
2. Region code is printed on product type plate. Due to DVD legislation region codes
different to assigned region may not be released.
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: NO POWER, NO GREEN LED
start
Check if the
power cable
and
AC adapter
OK?
no
replace cable/
adapter
set OK?
no
replace connector
and switch unit
no
yes
No defect, return
set to customer
yes
Check if the
power and play
button OK?
yes
replace MAIN
BOARD
go to other
SYMPTOM
SYMPTOM: NO IMAGE OR SOUND COMES OUT FROM THE EXTERNAL OUTPUT
start
Check
operation of
the DVD drive.
Does the DVD
drive work?
yes
Replace the main
board or the
connector
no
replace DVD drive
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE INITIAL SCREEN IS NOT DISPLAYED ON THE LCD
Refer to the
symptom NO
POWER, NO
GREEN LED
start
Check if the
LED on the
front lights up?
Replace broken
harness
no
yes
yes
Check if the
backlight is
OK?
Repair connector
no
Open the top and
bottom assembly
to check the
connector harness
Is the
connector
harness
broken?
no
no
Remove the LCD
cover and plate of
the LCD unit to
check the
connector of the
FL harness
Is the
connector OK?
yes
Replace FL
inverter or LCD
yes
Check if the
lighting of the
LCD is OK?
no
Open the top and
bottom assembly
to check the
connector to the
main board
Is the
connector
broken?
yes
yes
Replace LCD unit
or main board
Replace LCD
harness or main
board
Connect the LCD
harness to the
LCD unit
no
Remove the LCD
cover and plate of
the LCD unit to
check the
connection of the
harness to the
LCD unit
no
Is the
connection
OK?
yes
Replace LCD unit
or main board
SYMPTOM: NO IMAGE OR SOUND COMES OUT FROM THE EXTERNAL INPUT
start
Replace the main
board or the
connector
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE DVD DRIVE DOES NOT WORK
Press the DISC cover switch at the center
of the DVD player and turn on the power.
Then check whether or not the optical pickup lens of the DVD drive lights. CAUTION:
Visible laser radiation when open and
interlock defeated. Do not stare into Laser
beam.
start
yes
Check the
optical pick up
lens?
Replace DVD
drive
Pick up lens light up dim
Pick up lens does not light up at all
Check the
connectors of
the DVD drive
and main
board?
OK
Pick up lens light up OK
Not OK
Secure the
connection of the
DVD drive and
main board
Insert a DVD disc
and turn on the
power
The DVD drive works but the initializing operation of the optical pick-up lens
does not start (the optical pick-up lens operates twice), or abnormal noise
sound
DVD drive does not work
Replace DVD
drive or main
board
What is the
reaction of the
DVD drive?
The operation of the DVD player stops at initializing display.
oading?displayed
Is there any
message
shown on
display
HECK DISK?displayed
Does the
image output
stop during the
operation?
DVD disc OK
Check the DVD
disc for
fingerprints, dirt,
No defect, return
set to customer
Nothing on display
yes
Is the DVD
disc OK?
no
DVD disc dirty
5.0 TROUBLESHOOTING & SERVICE TIPS
SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY
start
Install a good battery does the LED lights up
orange while the AC adapter is connected and
does the DVD drive operate OK?
NOTE:
- For this check, use a battery which is not fully
charged (because the LED does not light when the
battery is fully charged.)
- Before this check, make sure other function work
correctly.
yes
Replace battery
no
Is the
connection of
the battery OK
inside the DVD
player?
no
Secure the
connection of the
battery harness
inside the DVD
player
yes
Replace main
board
SYMPTOM: NO SOUND COMES FROM THE HEADPHONES
start
Insert a good
headphones and check if
the problem persist?
yes
Replace main
board
no
Customer　headphones
defective
6.0 OVERALL BLOCK DIAGRAM
TC4W53
16M FlashROM
64M SDRAM
MX29LV160
HY57V641620
DC 9V
27MHz
74HCU04
24.576MHz
OSCILLATOR
OZ9RR
27MHz
RTD2011
RF AMP & SERVO & DVD PROCESSOR
MPEG-2 DECODER & VIDEO ENCODER
MT1389DE/H-L
DV23(HD80)
PU mechanism
+5V
DRIVER
(CMD5954)
R/G/B
TFT MONITOR
HIGH VOLTAGE ASS'Y
TVP5150AM
BA7660FS
VIDEO IN
+5V
+3.3V
+1.8V
14.31818MHz
DRIVER +5V
TFT POWER
R/G/B OUT
+3.3V +5V +2.5V 8.8V +16V -10V
VIDEO OUT
L
110~240V
50/60Hz
AC
Adapter
COAXIAL OUT
L
R
AUDIO +5V
AUDIO AMP
(AZ4558)
AUDIO D/A
(PCM1753)
R
AUDIO OUT
AUDIO +/-5V
AUDIO IN
DC IN +9V
DC / DC
BD9303/AO3401L/AO4801L
BA33BC0FP/BA50BC0FP
APS1006/AMC1117-2.5
BATTERY
TC74HC4052AFT
PHONE OUT
LM4863MT
(BQ2057C)
(TPC8207)
(VG202C)
SPEAKER LOUT
SPEAKER ROUT
1
2
XS1 3
4
TFT-GND
BRIGHT-CON
TFT ON/OFF
HV/9V
1
2
3
4
HV POWER PCB
7.0 OVERALL WIRING DIAGRAM
GND
GND
GND
DCIN
POWER SW
GND
Headphone L
Headphone R
USBP
USBM
1
2
3
4
5
6
7
8
9
10
11
12
SWITCH PCB
XS6
1
2
3
4
5
6
7
8
9
10
11
12
XS7
XS001
1
2
3
4
BATT+1
TS 2
GND 3
GND 4
BATTERY
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
1
2
3
4
XS008
5
6
MAIN PCB
XS5
1
2
3
4
5
6
7
8
9
10
11
12
DRIVE
LIMIT
GND
SLSL+
SP+
SP-
24
23
22
21
20
19
18 XS3
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
KEYOUT3
KEYOUT2
KEYOUT1
KEYOUT0
KEYIN3
KEYIN2
KEYIN1
KEYIN0
GND
+P5V
LED-CON
GND
1
2
3
4
5
6
NC
LD/VCC
V20
GND
F
E
CD/DVD SW
RF
C
D
B
A
VRCD
VRDVD
MD
LD/CD
GND
LD/DVD
NC
VCC
FCSTRK+
TRKFCS+
1
2
3
4
5
6
7
8
9
10
11
12
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
FUNCTION BUTTON PCB
XS1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
VCOMS
GND
3.3V
GND
B
G
R
GND
MODE2
MODE1
SPOI
SPIO
SPS
CLD
NC
CLS
GND
GND
TFT +5V
TFT +5V
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18 XS5
19
20
1
GND
2
GND
3
GND
4
-14.5V
5
GND
6
+16.5V
7
GND
8
3.3V
9
3.3V
10
GND
11
SPKL12 XS4
SPKL+
13
SPKR14
SPKR+
15
GND
16
GND
TFT ON/OFF 17
BRIGHT-CO 18
TFT-HV9V 19
TFT-HV9V 20
IF PCB
30
29
28
27
26
25
24
23
22
21
20
19
18
XS2 17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
VCOM
GND
A VDD 8.8V
V11T
V9T
V7T
V5T
V3T
V1T
R/L
BLU0
BLU1
BLU2
BLU3
BLU4
BLU5
LD
STHR
LCD VDD
DCLK1
GND
INV
STHL
GRN0
GRN1
GRN2
GRN3
GRN4
GRN5
GND
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
XS3 15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
GND
RED0
RED1
RED2
RED3
RED4
RED5
GND
V2T
V4T
V6T
V8T
V10T
A VDD 8.8V
GND
VCOM
U/D
V13T
VGH
V14T
VGL
V12T
LCD VDD
EDGSL
GND
STV1\DIO1
CPV
OE
STV2\DIO2
POL
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
1
2
3
4
LCD
GND
GND
ISEN
VSEN
1
2
3
4
AVDD3
256
CB138 R38
15K
255
254 100N
C100
253
100N
252
GND C102
251
100N
250
249
1N
248
C99
247
246
GND
245
ADCVDD3
244
47N C109
243
242
241
47N C110
240
PLLVDD3
239
470N C111
238
GND
237
C137
236 470N C111
750K R93 10U/16V
235
27M
234
233
RFV DD
232
GND
231
230
229
228
ASDATA0
227
226
C32
10U/16V
225
224
223
222
GND
221
220
219
C32
10U/16V
218
217
SPDIFOUT
216
$$$7
215
BAT-DET
214
V18
213
SD-CMD#
212
ACLK
211
ABCK
210
ALRCK
209
DV33
208
DVD/AUX#
207
TFTSW
206
SD-CD#
205
MS-CD#
204
MS-CLK#
203
MS-BS#
202
MS-DATA0#
201
MS-DATA1#
200
MS-DATA2#
199
MS-DATA3#
198
SD-CLK#
197
D ACVDDB
196
VREF
195
FS
194
$$$243
193
8.0 ELECTRICAL DIAGRAM
MAIN BOARD CIRCUIT DIAGRAM (MPEG & SERVO & AV OUT)
R36
10k
1
5
R39
20k
R081
10
BRIGHTCON
R10 10K
2
R5 1K
3
R080
N406
HS0038B
L1
+P5V
CB6
100n
R2
51K
HV
VD40 10K
+P5V
R3
47K
DTC144
601
DV33
R138
10
7
6
C1
10U/16V CB85
N2B
4558
D001
24C02
R407
10K
+
R003
47K
R56
10K
+P5V
5
DC
DV33
R55
10K
BATTER
1
CB3
100n
DV33
FMC3
N2A
4558
A0
A1
A2
A3
A4
A5
A6
A7
$$$201
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
100n
PCE#
PRD#
PWR#
R408
21
20
19
18
17
16
15
14
8
7
36
6
5
4
3
2
1
40
13
37
38
22
24
9
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
25
26
27
28
32
33
34
35
NC
NC
11
29
RESET
RY/BY
10
12
VCC
VCC
30
31
VSS
VSS
23
39
3Y
4A
7
GND
4Y
$$$231
$$$169
$$$138
$$$140
$$$142
$$$147
DQM1
DV33
LIMIT
DQ8
+
L15
64MSDRAM
C92
NC
L4
DV33
V2P8
AVDD3
R90
601
SVDD3
CB76
100n
10K
+
CB69
100n
CB47
100n
C125
10U/16V
C37
10U/16V
L31
1V8
V18
601
10K
CB116
100n
D005
8MFLASH
CB5 CB140 CB119 CB112
100n 100n
100n
100n
+ C96
10U/16V
V1P4
ACLK
15
ML
MC
14
MC
4
DGND
MD
13
5
+3.3V ZERONA
12
6
+5V
11
1k
+ C511
47U/16V
4k7
VD520
2SD601
VD524
KTA1298
VD522
7
R522
100k
C517
2n7
N501B
4558
3k9
C519
#DVD/AUX
+P5V
A-R
L-IN
2SD601
EM5
10M
300P
R526
R114
2SD601
R149
CB42
100n
VR2
R125
R158
CLOSESW
I11
ESF11V1
DV33
1k
N11
EM8
+
C166
C120
+
100U/6.3V
R71
10k
C150
100U/6.3V
10M
VD29
TFTSW
STZ6.2N
I81
ESF11V1
330N
JS1
EM7
0
10M
VD28
STZ6.2N
C143
+
470
1k
WX10HB-2-20K
VD14
2SD601
C147
R155
R156
10k
30k
C509 220uF/4V
R104
10k
HSJ1494-01010
100N
R113
10
R155
10U/16V
+
C163
A-L
+ C510
47U/6V
L22 601
N4863
C165
R106
10k 10k
VD407
KTA1298
1k
WX10HB-2-20K
DV33
LT1117-1.8V
10U/16V
R101
R560
+
VR1
N4
R454
10k
1V8
10
AUDIO5V
TC4052
-5V
R568
100k
30k
C509
10U/16V
VD4
2SD601
1k
1k
10k
1
2
3
4
R155
10U/16V
VD19
STZ6.2N
VD510
VD523
ISS355
D3
220uF/4V
R155
VD509
VD521
ISS355
C141
R176
+P5V
R527
1k
R567
100
C508 47uF/4V
C60 CB123 CB97 CB120 CB114 CB118 CB113 CB99 CB88 CB142 CB96
10U/16V 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N
DV33
R161
20
19
18
17
16
15
14
13
12
11
5
6
R520
10k
ISS355
VCC 5V
R521
5k6
R559
R557
R519
10
R150
R518
100
R529
100
C148
SHUTDOWN HP-IN
GND
GND
+OUT A
+OUT B
VDD
VDD
-OUT A
-OUT B
-IN A
-IN B
GND
BYPASS
+IN A
+IN B
NC
NC
NC
NC
VCC 5V
R558
10k
1k
100U/6V
100n
+
Speaker
R191
100k
10k
C504
C523
XS003
100k
1k R112
C281
100N
100U/6V
2n7
100k
R523
10k
1k
100N
10k
10
R103
C573
CB144
DTA124
+
R556
C574
100n
R516
DV33
VD26
R180
R111
+
+
R501
47K
10U/16V
VD525
ISS355
C516
R502
47K
10U/16V
C164
+
C555 47U/4V
R117
10k
+
8
R102
R593
10 AUDIO-5V
R160
16
15
14
13
12
11
10
9
7
ROUT
3
10M
VDD
2X
1X
X-COM
0X
3X
A
B
LOUT
GND
R514
3k9
R517
10k
R513
5k6
ISS355
0Y
2Y
Y-COM
3Y
1Y
INH
VEE
VSS
VCOM
C554
47U/4V
C34
100N 10U/16V
TFTON
1k
+P5V
EM4
1
2
3
4
5
6
7
8
9
100n
10k
+
+
R49
N501A
C509 47uF/4V R530
4558
100
1
+
10
C58
C59
ZERO OA
2
+
ISS355
10k
10K
DV33
CB78+
VD17
STZ6.2N
4
VD14
R01
R -IN
8
VD13
ISS355
MD
10K
R59
R192
VD25
300P
R515
+
+
D/AVCC
C518
C64 CB04 CB72
OP+
16
ML
LRCK
2
1
SCK
DATA
3
10U/16V
JS4
+
BCK
2
10
1
2
1
10U/10V
+
ABCK
ASDATEO
ALRCK
C32
C78 +
2200P 10U/16V 100N 100N
A_L
33
1
2
3
4
5
6
7
8
9
10
R30
CB129
100n
R28
680K
A_R
D02
PCM1742
100
EM7
R241
390
10U/16V
D004
AD0
AD1
AD2
AD3
AD4
AD5
AD6
AD7
CB94
100N+
R242
C52
CB110 CB111 CB115 CB145 CB103
100n 100n 100n 100n 100n
D11
MT1389HD
601
+P5V
10M
SDRAM3V3
CB100
100N
DV33
3
R156 10K
AVDD3
IREF
RFGC
OSN
OSP
RFGND
CRTPLP
HRFZC
RFRPAC
RFRPDC
RFVDD3
ADCVSS
ADCVDD3
LPFOP
LPFIN
LPFIP
LPFON
PLLVDD3
IDACEXLP
PLLVSS
JITFN
JITFO
XTALI
XTALO
RFVDD18
RFGND18
ADACVDD2
ADACVDD1
ALF/(CTR)
ALS/SDATA0
AL/SDATA2
AVCM
AR/SDATA1
ARS/SDATA3
ARF(SW)
ADACVSS1
ADACVSS2
APLLVSS
APLLCAP
APLLVDD3
SPDIF
MC_DATA
ASDATA4
DVDD18
ASDATA3
ACLK
ABCK
ALRCK
DVDD3
SPBCK
SPLRCK
SPDATA
SPMCLK
ASDATA2/GPO_0
ASDATA1/GPO_1
GPIO_3
GPIO_4
RCLKB/GPIO_5
RVREF/GPIO_6
ASDATA0/GPO_2
DACVDDC
VREF
FS
YUV0/CIN
V1P4
C53
150P
V1P4
R153 1K
4
2
C457
15N
V1P4
20k
#DC/BATTER-DET
N20
10 R154
BRIGHTCON#
R169
20k
R47
C49
330P
D003
BA5954
10K
R166
10k
TRO
V1P4
STBY
FMO
V1P4
R41
15K
V1P4
LIMIT
CB77
100n
R444
29
7
6
5
4
3
2
1
6
6
12
46
52
R48
20k
C54
150P
CB77
330P
R40
15K
G1
VNFFC
VOSL
VINSLVINSL+
CF2
CF1
VINFC
RN5
5Y
VSSQ
VSSQ
VSSQ
VSSQ
PREGND
VINLD
CTK2
CTK1
VINTK
BIAS
STBY
22*4
5A
3A
VSS
VSS
VSS
G2
22
23
24
25
26
27
28
100n
6Y
2Y
5
54
41
28
30
CB40
2A
4
C93
601
1310U/16V
+ CB117
12
100n
11
R570
33
C208
10
100n
R312
SPDIFOUT
9
33
8
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
C416
10U/10V
0R5
R58
10
3
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
+
10k
14
13
12
11
10
9
8
R52
R53
DVDD3
IOWR#
A16
HIGHA7
HIGHA6
HIGHA5
HIGHA4
HIGHA3
HIGHA2
HIGHA1
IOA20
IOCS#
IOA1
IOCE#
AD0
AD1
DVSS
AD2
AD3
AD4
AD5
AD6
IOA21
ALE
AD7
DVSS
A17
IOA0
DVDD18
UWR#
URD#
DVDD3
UP1_2
UP1_3
UP1_4
UP1_5
UP1_6
UP1_7
UP3_0
UP3_1
UP3_4
UP3_5
ICE
PRST#
IR
INT0#
DQM0
IO_19
RD7
RD6
RD5
RD4
RD3
DVDD3
RD2
RD1
RD0
RD15
RD14
RD13
RD12
RD11
RD10
RD9
601
R1
VOFC+
VOFCVOSL+
VOSLPGND
PVCC1
VCC
4
DV33
CB79
100n
VOTK+
VOTKVOLD+
VOLDPGND
VNFTK
PVCC2
F00
DRVCC
15
16
17
18
19
20
21
33
33
DV33
PWR#
A16
A15
A14
A13
A12
A11
A10
A9
A20
PCE#
A1
PRD#
AD0
AD1
GND
AD2
AD3
AD4
AD5
AD6
A21
0R5
L015
53261-0690
8
R50
22P
C75
5.1P
L19
14
3
9
43
49
R162
1
6
5
4
3
2
1
C62
NC
NC
R43
VD16
FMC3
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10/AP
A11
BA0/A13
BA1/A12
R167
150K
CLK3
10k
TFTON-OFF
VD9
DTC144
TFTOFF
R16
0
C466
TZC03A200P
D002
74HCU04
C63
1N
1 1A
VCC
R57
1M
2 1Y
6A
G2
27M
36
40
R163
150K
R4
1
14
27
4.7
KTA1298
+P5V
VCC
VCC
VCC
VD10
FCS+
MOLEX-2409
CS
VCCQ
VCCQ
VCCQ
VCCQ
LDO2
DV33
MA4
MA5
MA6
MA7
MA8
MA9
MA11
GND
DCKE
DCLK
DV33
MA3
MA2
V18
MA1
MA0
MA10
PAL/N
DQML
DQMH
R98
CS
5015RESET/RD2011
$$$6
$$$3
BRIGHTCON#
V18
Y0
15
39
NC
KEYOUT1
KEYOUT2
KEYOUT3
1
2
3
4
5
6
7
8
23
24
25
26
29
30
31
32
33
34
22
35
20
21
C118
10u/6v
C48
Y4
KE YIN0
KE YIN1
KE YIN2
KE YIN3
KEYOUT0
KEYOUT1
KEYOUT2
KEYOUT3
DQM0
DQM1
C97
4700P
Y5
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
MA9
MA10
MA11
$$$169
$$$231
R23
10
R140 0
LDOVCC
LDO1
RMC
L21
VCC 601
C187 1uF
+
C119
10U/16V
R99
+
4.7
Y6
XS1
MOLEX-0890
CLK
CKE
CS
RAS
CAS
WE
DVDC
VD11
8
7
6
5
KTA1298
L22 601
DVSYNC
38
37
19
18
17
16
1uF
DVDD
#MA
DVDB
R139 0
1uF
MC
R148
#SCL
#SDA
C46
C44
0
VDD
NC
SCL
SDA
DVDA
1uF
$MD
0
Y7
$$$127
D CKE
$$$138
$$$140
$$$142
$$$147
C47
R137
TFTONOFF
HSY
27M
LD/VCC
A0
A1
A2
A3
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Pin Assignment v1.5
1
DCLK
3
4
5
XS4
GND
#Y
DACVDDB
#C
GND
CVBS
DACVDDB
G
GND
B
R
SD-DATA0#
SD-DATA1#
SD-DATA2#
GND
V18
KE YIN0
KE YIN1
DV33
KE YIN2
KE YIN3
KEYOUT0
1
LDO2
LDO1
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
2
4
5
7
8
10
11
13
42
44
45
47
48
50
51
53
CB68 CB67
100n 100n
1
2
3
4
D1
TC4W53
MT1389HD
5
FMC3
2
VCC
+
COMMON
INH
VEE
VSS
1
2
3
4
DTC144
VD14
2
4
R44
10K
DACVSSC
YUV1/Y
DACVDDB
YUV2/C
DACVSSB
YUV3/CVBS
DACVDDA
YUV4/G
DACVSSA
YUV5/B
YUV6/R
VSYNC/V_ADIN1
YUV7
HSYNC/V_ADIN2
DVSS
IO_17
C0/IO_0
C1/IO_1
DVDD18
C2/IO_2
C3/IO_3
C4/IO_4
DVDD3
C5/IO_5
C6/IO_6
C7/IO_7
YUVCLK/IO_8
Y0/IO_9
Y1/IO_10
Y2/IO_11
Y3/IO_12
Y4/IO_13
DVDD18
Y5/IO_14
Y6/IO_15
Y7/IO_16
DVDD3
RA4
RA5
RA6
RA7
RA8
RA9
RA11
DVSS
CKE
RCLK
DVDD3
RA3
RA2
DVDD18
RA1
RA0
RA10
BA1
BA0
RCS#
RAS#
CAS#
RWE#
DQM1
DVDD3
IO_18
RD8
VCC
GND
RMC
5
6
7
8
AGND
DVDA
DVDB
DVDC
DVDD
DVDRFIP
DVDRFIN
MA
MB
MC
MD
SA
SB
SC
SD
CDFON
CDFOP
TNI
TPI
MDI1
MDI2
LDO2
LDO1
SVDD3
CSO/RFOP
RFLVL/RFON
SGND
V2REFO
V20
VREFO
FEO
TEO
TEZISLV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
PWMOUT1/V_ADIN9
TRO
FOO
VPLLVSS
CAPPAD
VPLLVDD3
USB_VSS
USBP
USBM
USB_VDD3
FG/V_ADIN8
TDI/V_ADIN4
TMS/V_ADIN5
TCK/V_ADIN6
TDO/V_ADIN7
DVDD18
IOA2
IOA3
IOA4
IOA5
IOA6
IOA7
HIGHA0
IOA18
IOA19
1
2
3
F
E
MD
A
CH1
CH0
VDD
3
TFT ON
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
AD7
89
GND
90
A17
91
A0
92
V18
93
94
95
DV33
96
HSY
97
MC#
98
#DC/BATTER-DET 99
MD#
100
#SCL
101
#SDA
102
ML
103
TFTONOFF
104
RXD
105
TXD
106
107
RERST
108
IR
109
110
DQM0
111
CD/DVD
112
DQ7
113
DQ6
114
DQ5
115
DQ4
116
DQ3
117
DV33
118
DQ2
119
DQ1
120
DQ0
121
DQ15
122
DQ14
123
DQ13
124
DQ12
125
DQ11
126
DQ10
127
DQ9
128
V20
CD/DVD
+
1
2
3
4
5
6
7
#MA
8
#MB
9
MC
10
$MD
11
12
13
14
15
16
17
E
18
F
19
MD
20
21
22
23
SVDD3 24
25
26
GND
27
V2P8
28
V20
29
V1P4
30
31
100N CB139 32
33
OPO
34
OP35
OP+
36
#DMSO
37
FMO
38
39
40
TRO
41
F00
42
GND
43
44
45
GND
46
#USBP
47
#USBM
48
USB_VDD 49
FG
50
51
CLOSESW 52
STBY
53
54
V18
55
A2
56
A3
57
A4
58
A5
59
A6
60
A7
61
$$$201
62
A18
63
A19
64
C30
10U/10V
10K
N20
+
GND
DVDA
DVDB
DVDC
DVDD
$$$251
R24
1k
R133
+P5V
R155
1k
XS004
Speaker
HSJ1494-01010
COX
8.0 ELECTRICAL DIAGRAM
MAIN BOARD CIRCUIT DIAGRAM (DC POWER)
#HV9V
C077
16v/100u
C088
100N
L005
CDRH6D38-330MC
C28
100N
C091 C024 C167
10U/10V 100N100U/10V
DRVCC 5V5
CATION:REPLACE PUSE WITH SAME
5.5V OUT
TYPE AND RATI NG
VD101
BA05
T3A/125V
BRIGHT CON
27K
2
R29
4K7
C207
30P
C151
1N
R179
R175
18K
R177
20K
C153
1N
R180
20K
R182
56K
R176
68K
R002
1K
R10
510
24
3
COMP1
BOOT1
23
4
FB1
SW1
22
5
VREF
SW1
21
6
GND
REG
20
C150
30P
C154
1U
C155
47N
C147
100N
L37
CDRH6D38-330MC
CB6
CB38 C204
100N 100N 10U/16V
N6
BA033
100N 100N 10U/16V
1
IN
VD1
C194
2.2U
OUT
7
FB2
B240A
8
COMP2
9
INV3
19
SW2
18
3.8V OUT
10
FB3
11
COMP3
BOOT2
16
12
CDET
PVCC2
15
13
SS
SW3
14
SW2
C152
100N
17
VD33
1
IN
OUT
2
CB108
100N
DVD 3V3
100U/16V
8
7
6
5
C156
16v/100u
VD001
UPA1716G
CB1
100N
R02
R104
1K
L2
VD32
DTA124
C113
10U/10V
C132
100N
R105
7K5
R124
7K5
R22
4K7
1
OUT
OUT
20
2
STAT1
STAT2
19
3
IN
PGND
18
4
IN
PGND
17
5
PG-
CE-
16
6
VCC
SNS
15
7
TTC
BAT
14
8
ISET1
CELLS
13
9
ISET2
TS
12
VTSB
11
10
VSS
N102
BQ24103
C131
1U
C66
16V/10U
C2
16V/10U C50 R03
C55
C45
100N
16V/10U 16V/10U
CDH124-100MC
1K
VD002
47K
4
3
2
1
5
6
7
8
UPA1716G
2
R103
C051
SLITE100MF
100N
R129
6K 2
R68
NC
R86
0R5
F004
0430005NR
1
TS
C24
16V/10U
C25
0
100U/16V
AUDIO -5V
C049
100UH
B240A
LED
VD01
C020
L36
- 5V OUT
L33
220UH
BA033
C020
100U/16V
B240A
N101
BD9303FP
1
2
3
4
L39
CDRH6D38-330MC
VD2
VD105
D5
LT1117
FIN
PGND
220UH
TFT2.5V
TFT3.3V
2
1
FIN
SW001
SSSS716603
VD9
DTC144
PVCC1
2
3
4
C149
1U
ENB
C67
1
R118
15K
2
C180
100U/16V
10U/10V
R7
20K
25
C10
C143
1N
VCC
10U/10V
CB10
100n
VD6
IN5402
RT
CB122
C001
100N
1
C84
L33
100N
R173
51K
+P5V
CB65 C02
3
C144
30P
B240A
R118
51K
2
OUT
GND
VD004
C139
100N
IN
R2
75
3
1
C11
16v/100u
R225
1K
B240A
GND
4
VD003
3
FM001
LV-R0484
3
2
1
F003
0430003WR
2
1
2
JS001
HEC4801-010010
C04 C05 C254 C80
C89
100N 100N 100N 10U/16V 100U/16V1
GND
Nkvvgnhwug
C23
16V/10U
JS102
1
2
3
4
5
6
7
TO BATTERY
MOLEX-53261-0790
R131
33K
R132
10K
8.0 ELECTRICAL DIAGRAM
8.0 ELECTRICAL DIAGRAM
MAIN BOARD CIRCUIT DIAGRAM (TFT)
L4
R248
L57
R244 1M
100
94
93
92
C226 47nF
C227 47nF
96
95
R243 100
2
2
1
1
1
Seper ate here
cance
lL
9
2
2
J2
22 2
22 2
3PVCC
2
DPLL_VDD
DPLL_GND
APLL1_VDD
APLL1_GND
84
83
APLL2_VDD
APLL2_GND
85
86
APLL3_VDD
APLL3_GND
1
1
R283
10
2
2 RD2011RESET
RESET
Y
B
8051
CS
MD#
MC#
2.5DVCC
2.5DVCC 1
2
1
FEB_0805
C45
100nF
100nF/0603
1
100nF
R2.5DVCC
2
L5
C213
1
2
2
2
100nF
1
1
1
100nF
C212
1
2
2
2
C211
C195
10nF 100nF
1
10U/16V 1nF
1
2
2
2
1
1
1
2
2
2
2
1
1
1
1
TFT_9V
1
12
25
40
53
72
110
125
11
26
39
54
71
109
126
GNDK
GNDK
GNDK
GNDK
GNDK
GNDK
GNDK
J1
DBBLU0
DBBLU1
DBBLU2
DBBLU3
DBBLU4
DBBLU5
DBBLU6
DBBLU7
127
128
1
2
3
4
5
6
DBGRN0
DBGRN1
DBGRN2
DBGRN3
DBGRN4
DBGRN5
DBGRN6
DBGRN7
7
8
13
14
15
16
17
18
DBRED0
DBRED1
DBRED2
DBRED3
DBRED4
DBRED5
DBRED6
DBRED7
19
20
21
22
27
28
29
30
DABLU0
DABLU1
DABLU2
DABLU3
DABLU4
DABLU5
DABLU6
DABLU7
35
36
41
42
43
44
45
46
DAGRN0
DAGRN1
DAGRN2
DAGRN3
DAGRN4
DAGRN5
DAGRN6
DAGRN7
47
48
49
50
55
56
57
58
DARED0
DARED1
DARED2
DARED3
DARED4
DARED5
DARED6
DARED7
61
62
63
64
67
68
69
70
1
100nF/0603
2
1
2
3
4
BK_EN
CON2-A2.00
1R077 100 2 ON/ OFF
BK_BRIT
1R074 220 2 VBRI_5N
C089
1uF
R147 22
OE 4
RP3
DABLU2
DABLU3
DABLU4
DABLU5
DABLU6
DABLU7
TCON-10
DA GRN2
DA GRN3
DA GRN4
DA GRN5
DA GRN6
DA GRN7
5
6
7
8
4
3
2
1
D0[5:0] 4
5
6
7
8
22_4
RP5
5
6
7
8
4
3
2
1
4
3 22_4
2
RP6
1
5
6
7
8
22_4
RP7
TCON-8
5
TCON-9
6
D ARED2
7
D ARED3
8
D ARED4
D ARED5
D ARED6
22_4
D ARED7
D 00
D 01
D 02
D 03
D 04
D 05
RP4
4
3
2
1
CPV
4
3
2
1
22_4
RP8
5
6
7
8
DHS
DCLK
DVS
DEN
DDC_SCL
DDC_SDA
C095
100uF_16V
2
VCCK
VCCK
VCCK
VCCK
VCCK
VCCK
VCCK
VCCO
VCCO
VCCO
VCCO
VCCO
VCCO
VCCO
4
3
2
1
CPV 4
D1[5:0] 4
D 10
D 11
D 12
D 13
D 14
D 15
POL
STB
D 20
D 21
D 22
D 23
D 24
D 25
POL 4,5
STB 4
22_4
33
34
60
59
108
107
ON/ OFF_1 2
PWM1/REF_CLK
PWM0
2
9
R284
0
+
32
31
1
C200
10U/16V
ON/OFF_1
PLL_TEST1
PLL_TEST2
BCLK
B0
B1
B2
B3
B4
B5
B6
B7
RESET#
14
2
U5D
80
81
122
114
115
116
117
118
119
120
121
1 2
R145
1
1
8
1
10K
74HC14
ON/ OFF
24.576MHz
74 XO
3DVCC
VCC
TFT_9V
2
R136
V BRI
13
G4
104
2
VBRI_5N 12
2
C201
1
20F
R330
1M
R
TD2011
PLL_GUARD_VDD
PLL_GUARD_GND
XI
SCLK
SDI/SDO
SCSB
2
2
1
1
2
1
14
1
1
2
U5F
74HC14
2
2
5D_VCC 1
7
1
1
2
2
GUARD_VDD
GUARD_GND
79
82
75
76
73
7
1
1
2
2
PLL_GND
C196
VCC
10K
C63
NC
ADC_REFIO
78
77
1
1
1
1
1
22pF12pF
C23 NC
C76 NC
C5
100nF/0603
7V
ADC_VDD
ADC_GND1
ADC_GND0
2
1
2
2
C46 C47
1
1
2
L10 FEB_0805
C67
+ C66
C72
C68
C69
C71
100nF/0603
100nF/0603
100nF/0603 22uF_10V_TA
100nF/0603
100nF/0603
PLL_GND
2
120F
2
2
2
1 3PVCC
R51
R502K
1K
7V
ADC_R_VDD
R
ADC_R_GND
113
112
111
1R48
1R49
5D _VCC
C70 100nF/0603
CON20
R/VGA
DG ND
B/VGA
DG ND
G/VGA
DG ND
H SIN
DG ND
V SIN
C22 100nF/0603
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
SOG
G
90
91
88
1
2
1
3
ADC_B_VDD
B
ADC_B_GND
7
4
7
1
AHS
AVS
99
98
97
C214 C279 C280 C232
C65
10nF 100nF100nF 100nF 1
89
2
22uF_10V
ADC _GND
100nF/0603 100
87
+ C58
100nF/0603
2
2
2
U5B
74HC14
14
14
C230 22pF
ADC_VCC
1
2
L9 FEB_0805
C59
1 3PVCC
1
2
100nF/0603
R251 100
C231 47nF
1
C229 5p
ADC3PVCC
_GND
L55FEB_0805
R249 75
R47
0
C181 C172
1
C221 47nF
R247 100
C224 22pF
AHS
10U/16V 10U/16V
C190
2
C222 22pF
L56
FEB_0805
U5A
74HC14
1
GNDO
GNDO
GNDO
GNDO
GNDO
GNDO
GNDO
GNDO
12pF
C223 5p
C25
C199
C094
C197
10
10
23
38
51
66
106
123
R200 22
101
103
ADC _GND
FEB_0805
R245 75
C225 5p
R/VGA
1
9
24
37
52
65
102
105
124
R218
HSY
ADC _GND
R246 75
VCC
C171 +
TFT_9V
12pF
R230
2K
5DV CC R046 NC
R047
0
3DV CC
10U/16V 10U/16V 10U/16V
C19 +
C197
R230
2K
G/VGA
C132 +
R200 22
10
B/VGA
1
1
1
2
2
2
2
2
2
2
2
2
2
R218
1
+ C151 + C133 +
CB61 C191 C194 C193 C216 C182 C237 C189 C174
10U/16V 10U/16V 10U/16V 10U/16V 10U/16V 10U/16V 10U/16V 10U/16V 10U/16V10U/16V100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF
VSY
1
1
2
2
2
2
2
2
2
+ C144 + C209 + C219 + C218 + C220 + C175 + C152 + C207
+ C206 + C9
2
2
1
1
1
1
1
1
1
1
2
FEB_0805
1
R3DVCC
3DVCC
1
1
1,2 3DVCC
ADD DEBUG PORT
CON10
1
2
3
DEBUG PORT
TCON-1
1R62
22 2
PLSR
TCON-0
1R63
22 2
I NV
TCON-ECLK 1R64
22 2
C LK
C77
12pF
PLSR4
INV 4
CLK 4
DG ND
DGND
8.0 ELECTRICAL DIAGRAM
D2[5:0] 4
8.0 ELECTICAL DIAGRAM - HIGH VOLTAGE BOARD CIRCUIT DIAGRAM
D1
3
2
1
C11
R11
C3
R6
R2
F1
DIV2 DIV1
VSEN
GNDAVDDA
CT
ENA
ISEN
CN1
IC1
1
2
3
2
4
C1
R1
Q1
C2
U1
S1D1
G1D1
S2D2
G2D2
8
1
C8
7
5
C9
1
4
R5
C4
3
D2
UI8.5
1
R8
R10
R3
SOT-23
Q4
Q3
SOT-23
CN2
C10
2
6
5
T1
R4
C6
R9
3
2
1
C7
1210
9.0 COMPONENT LAYOUT
PET1000 HV POWER BOARD DIAGRAM
PET1000 IF BOARD DIAGRAM
9.0 COMPONENT LAYOUT
PET1002 SWITCH BOARD DIAGRAM
9.0 COMPONENT LAYOUT
PET1002 MAIN BOARD DIAGRAM
10.0 SERVICE PARTS LIST
Model#
Part No.
Description
Photos
Location Code
BATTERY
PET1002
PET1008
994000003941
RB-LI65 LITHIUM BATTERY
RC
PET1002
PET1008
994000003945
RC810 REMOTE
AVCABLE
PET1002
PET1008
994000001912
AV CABLE
CCABLE
PET1002
PET1008
994000002585
CHROMATISM CABLE
SVCABLE
PET1002
PET1008
994000002586
S-VIDEO CABLE
994000003524
ADPV18A AC POWER
ADAPTOR/05
ACADAPTOR
PET1002/05
ACADAPTOR
PET1002/00
PET1008/00
994000003946
AC POWER ADAPTOR/00
ACADAPTOR
PET1002/37
994000003947
ADPV26A AC POWER
ADAPT0R/37
996500042048
ADPV25A AC POWER
ADAPTOR/93
ACADAPTOR
PET1002/93
CARADAPTOR
PET1002
PET1008
994000003948
CAR CIGARETTE ADAPTER
/00/05/37
10.0 SERVICE PARTS LIST
BAG
PET1002
PET1008
994000001914
TRAVEL BAG
100
PET1002
PET1008
994000003942
PET1002M MAIN PCB ASS’Y
110
PET1002
PET1008
994000002583
PET1000 IF PCB ASS’Y
120
PET1002
PET1008
994000002159
PET1000 HV PCB ASS’Y
PET1002
PET1008
994000003944
PET1002 FUNCTION PCB
ASS’Y
130
142
PET1002
PET1008
994000002241
20 PIN HARNESS (LE105)
146
PET1002
PET1008
994000002584
20 PIN HARNESS (LE165)
150
PET1002
PET1008
994000003943
PET1002 SWITCH PCB
ASS’Y
200
PET1002
PET1008
994000002163
PET1000 TFT LCD
210
PET1002
PET1008
994000002228
DV23 LOADING ASS’Y
10.0 SERVICE PARTS LIST
220
PET1002
PET1008
994000002165
SPEAKER
230
PET1002
PET1008
994000003561
SPEAKER GRILL
300
PET1002
PET1008
994000003949
TOP COVER
DISCRETENESS
310
PET1002
PET1008
994000002591
DISPLAY FRAME
320
PET1002
PET1008
994000002589
MIDDLE CABINET
330
PET1002
PET1008
994000003951
BASE COVER
350
PET1002
PET1008
994000002992
KEY DISCRETNESS
360
PET1002
PET1008
994000002166
DOOR DISCRETNESS
410
PET1002
PET1008
994000002593
DOOR SPRING
10.0 SERVICE PARTS LIST
The following service BOMs are applied for all version unless specified.
Description
Photos
Location
Code
Model#
Service 12NC
PET1002
PET1008
996510002088
ON / OFF KNOB
420
PET1008/00
314017910141
DTM150 TECHNICAL SET
500
PET1008/00
314107941051
ADAPTOR AC TO DC 9V
1.11A
PET1008/00
314107941041
ANTENNA CABLE
PET1008/00
313923810891
RC19137008/01 REMOTE
PET1008/00
31410791061
SCART CABLE AY3929
ACADAPTOR
ANTENNA
RC
SCABLE
11.0 REVISION LIST
Version 1.0 (3141 785 30820)
• Initial release PET1002/00/05/37
Version 1.1 (3141 785 30821)
Chapter 10
• Add new spare part 996500039077 ADPV25A ADAPTOR/93
Version 1.2 (3141 785 30822)
Chapter 10
• Revised 12NC of ADPV25A ADAPTOR/93 to 996500042048
• Added the location code of all spare parts
Version 1.3 (3141 785 30823)
Chapter 10
• Added new spare part for PET1008
Version 1.4 (3141 785 30824)
Chapter 10
• Added new spare part 996510002088 ON/OFF POWER KNOB