No category

Download IC-F30G Service manual

Transcript

iC-f30gt
ic-f30gs
iC-f31gt
ic-f31gs
VHF TRANSCEIVER
iC-f30gt
iC-f30gs
iC-f3 1 gt
iC-f3 1 gs
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-13805MZ-C1-w
© 2002 Icom Inc.
INTRODUCTION
This service manual describes the latest service information for
the IC-F30GT/GS and IC-F31GT/GS VHF TRANSCEIVER at
the time of publication.
To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than 10 V. This will ruin the
transceiver.
DO NOT expose the transceiver to rain, snow or any liquids.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100
mW) to the antenna connector. This could damage the
transceiver’s front end.
INTERINSICALLY SAFE QUALIFICATION
When servicing intrinsically safe versions of the IC-F30GT/GS
and IC-F31GT/GS the following conditions must be met.
Failing to satisfy any of these conditions will invalidate the
INTRINSICALLY SAFE certification.
1. Servicing the transcever should only be undertaken by
suitably qualified personnel in a non-hazardous area.
Never attempt to remove the case in a hazardous area.
2. ONLY the approved battery, ICOM’s BP-210FM may be
used.
3. USE ONLY safety critical components as specified in the
parts list (SECTION 6), should replacement of any item
be necessary.
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : 06 6793 5302
Fax
: 06 6793 0013
URL : http://www.icom.co.jp/world/index.html
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1. 10-digit order numbers
2. Component part number and name
3. Equipment model name and unit name
4. Quantity required
< Corporate Headquarters >
IC-F30GS
IC-F31GS
IC-F30GT
IC-F31GT
<SAMPLE ORDER>
1110001810 S.IC TA7368F
8930053170 2337 Key board
IC-F30GT
IC-F31GS
MAIN UNIT 1 piece
CHASSIS
5 pieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1. Make sure a problem is internal before disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is disconnected from its power source.
3. DO NOT force any of the variable components. Turn them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the transceiver is defective.
6. DO NOT transmit power into a signal generator or a sweep generator.
7. ALWAYS connect a 40 dB or 50 dB attenuator between the transceiver and a deviation meter or spectrum analyser when
using such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : (425) 454-8155 Fax : (425) 454-1509
URL : http://www.icomamerica.com
< Customer Service >
Phone : (425) 454-7619
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : (604) 952-4266 Fax : (604) 952-0090
URL : http://www.icomcanada.com
Communication Equipment
Himmelgeister Str. 100, D-40225 Düsseldorf, Germany
Phone : 0211 346047 Fax : 0211 333639
URL : http://www.icomeurope.com
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
Phone : (93) 590 26 70 Fax : (93) 589 04 46
URL : http://www.icomspain.com
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : 01227 741741 Fax : 01227 741742
URL : http://www.icomuk.co.uk
A.B.N. 88 006 092 575
290-294 Albert Street, Brunswick, Victoria, 3056, Australia
Phone : 03 9387 0666
Fax : 03 9387 0022
URL : http://www.icom.net.au
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : 09 274 4062
Fax : 09 274 4708
URL : http://www.icom.co.nz
Zac de la Plaine, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
Phone : 561 36 03 03 Fax : 561 36 03 00
URL : http://www.icom-france.com
6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : (02) 2559 1899 Fax : (02) 2559 1874
TABLE OF CONTENTS
SECTION 1
SPECIFICATIONS
SECTION 2
INSIDE VIEWS
SECTION 3
DISASSEMBLY INSTRUCTIONS
SECTION 4
CIRCUIT DESCRIPTION
4-1
RECEIVER CIRCUITS ................................................................................................... 4 - 1
4-2
TRANSMITTER CIRCUITS ............................................................................................ 4 - 2
4-3
PLL CIRCUITS................................................................................................................. 4 - 3
4-4
POWER SUPPLY CIRCUITS ......................................................................................... 4 - 4
4-5
CPU PORT ALLOCATIONS ........................................................................................... 4 - 4
SECTION 5
ADJUSTMENT PROCEDURES
5-1
PREPARATION................................................................................................................ 5 - 1
5-2
PLL ADJUSTMENT.......................................................................................................... 5 - 4
5-3
SOFTWARE ADJUSTMENT ........................................................................................... 5 - 5
SECTION 6
PARTS LIST
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
SECTION 8
SEMI-CONDUCTOR INFORMATION
SECTION 9
BOARD LAYOUTS
9-1
FRONT UNIT ................................................................................................................... 9 - 1
9-2
MAIN UNIT....................................................................................................................... 9 - 2
SECTION 10
BLOCK DIAGRAM
SECTION 11
VOLTAGE DIAGRAM
SECTION 1
SPECIFICATIONS
RECEIVER
TRANSMITTER
GENERAL
USA/GEN
EUR
Measurement method
EIA-152-C/204D or TIA-603
Frequency coverage
136.000–174.000 MHz
Type of emission
16K0F3E [25 kHz; Wide], 8K50F3E [12.5 kHz; Narrow]
Number of conventional channels
Max. 256 ch (16 channels × 16 banks)
Power supply requirement
7.2 V DC (negative ground; supplied battery pack)
Current drain (approx.)
ETS 300 086 (GEN)
TX at High
2.0 A
Rx rated audio 300 mA
stand-by
95 mA (typical)
Frequency error
±2.5 ppm
±1.5 kHz
Usable temperature range
–30˚C to +60˚C (–22˚F to +140˚F)
–25˚C to +55˚C (–13˚F to +131˚F)
Dimensions (proj. not included)
54(W) × 139(H) × 38(D) mm; 21⁄8(W) × 515⁄32(H) × 11⁄2(D) inch
Weight (with BP-210)
420 g; 14.8 oz
RF output power
5 W / 2 W / 1 W (High/Low2/Low1)
Modulation system
Variable reactance frequency modulation
Maximum permissible deviation
±5.0 kHz [Wide], ±2.5 kHz [Narrow]
Spurious emissions
73 dBc typical
Adjacent channel power
70 dB [Wide], 60 dB [Narrow]
Audio frequency response
+2 dB to –8 dB of 6 dB/octarve
range from 300 Hz to 3000 Hz [Wide]/2550 Hz [Narrow]
Audio hormonic distortion
3% typical at 1 kHz, 40% deviation
FM hum and noise (typical)
46 dB [Wide], 40 dB [Narrow]
——
Residual modulation (typical)
——
45 dB [Wide], 43 dB [Narrow]
Limitting charact of modulator
60–100% of max. deviation
Ext. microphone connector
9-pin multi connector/2.2 kΩ
Receive system
Double-conversion superheterodyne system
Intermediate frequencies
1st: 31.65 MHz, 2nd: 450 kHz
Sensitivity (typical)
0.25 µV at 12 dB SINAD
–4 dBµV (emf) at 20 dB SINAD
Squelch sencitivity (at threshold) (typical)
0.25 µV
–4 dBµV (emf)
Adjcent channel selectivity (typical)
73 dB [Wide], 63 dB [Narrow]
Spurious response
70 dB
Intermoduration (typical)
74 dB
70 dB
FM hum and noise (typical)
46 dB [Wide], 40 dB [Narrow]
——
Hum and noise (with CCITT filter) (typical)
——
45 dB [Wide], 43 dB [Narrow]
Audio output power (at 7.2 V DC)
500 mW typical at 5% distortion with a 8 Ω load
600 mW typical at 5% distortion with a 6 Ω load
External SP connector
9-pin multi connector/8 Ω
All stated specifications are subject to change without notice or obligation.
1-1
0.25 µW
SECTION 2
INSIDE VIEWS
• MAIN UNIT
Top view
Antenna switching
(D1, D25, D24: MA77
D1 is bottom side)
D/A converter
(IC27: M62334FP)
• FRONT UNIT
Bottom view
Internal speaker switch circuit
(Q6, Q7: CPH3403, Q8: 2SC4081,
Q9: DTC144EUA)
Power amplifier
(Q1: 2SK2974)
Pre-drive amplifier
(Q2: 2SK2973)
2nd IF filter (450 kHz)
(FI2: SFPCA450KE4A)
(FI3: SFPCA450KG1A)
TX/RX switch
(D5, D4: MA77)
YGR amplifier
(Q3: 2SC4226)
TX/RX VCO circuit
Discreminator
(X2: CDBCB450KCA24 450 kHz)
PLL IC
(IC1: SA7025DK)
3.58 MHz crystal
(X4: CR-563
3.579545 MHz)
PTT/MD1 switch and
INT/EXT microphone switch
(IC19: BU4053BCF)
LCD module
(DS10: EDMMU1FA0)
Expander IC
(IC1: TC74VHC373FT)
• MAIN UNIT
Bottom view
S5 regulator
(Q31: 2SA1362)
+5 regulator
(Q32: 2SB1132)
R5 regulator
(Q30: 2SA1362)
KEY LED switch
(Q1, Q2: 2SC4116)
2nd mixer/IF detect
/SQL amplifier
(IC3: TA31136FN)
1st IF amplifier
(Q18: 2SC4215)
TCXO
(X1: CR-667
15.600 MHz )
AF amplifier
(IC5: TA7368F)
D/A converter
(IC13: M62364FP)
Crystal oscillator
for CPU clock
(X3: CR-681 12.288 MHz)
T5 regulator
(Q29: 2SA1362)
RF amplifier
(Q20: 3SK293)
Power detector
(D2: MA713)
APC amplifier
(IC4: TC75S51F)
1st mixer
(Q19: 3SK206)
1st IF filter
(FI1: FL-322 31.650 MHz)
Splatter filter
(IC7: NJM2902V)
Microphone amplifier/mute
/compander
(IC9: TC35453F)
DTMF decoder
(IC17: LC73872M)
CPU
(IC14: HD64F2238FA13)
Expander IC
(IC23: BU4094BCFV)
EEPROM
(IC16, IC24: HN58X2464TI)
2-1
SECTION 3
DISASSEMBLY INSTRUCTIONS
1 Removing the chassis panel
3 Removing the MAIN unit
J
I
I
B
A
Chassis
E
G
H Nut
MAIN unit
D
C
Front panel
Chassis
9-pin connector
q Remove 2 knobs A, and unscrew 1 nut B.
w Unscrew 1 screw C (ICOM screw), and 2 screws D (2 ×
4 mm, black) from the 9-pin connector.
e Unscrew 2 screws E (2 × 8 mm, silver) from the chassis.
r Take off the chassis in the direction of the arrow.
q Unsolder 2 points G.
w Unscrew 2 nuts H.
e Unscrew 6 screws I (2 × 4 mm, silver), and 2 screws
(2 × 4 mm, black) from the MAIN unit.
r Take off the MAIN unit in the direction of the arrow.
2 Removing the shield plate
4 Removing the FRONT unit
J
K
F
Shield plate
Front unit
J2
K
F
J1
F
MAIN unit
Front panel
F
Flexible cable
LCD flexible cable
Chassis
q Unplug the flexible cable from J1 on the FRONT unit to
separate the chassis.
w Take off the flexible cable in the direction of the arrow.
e Unscrew 8 screws F (2 × 3 mm, black) to separate the
shield plate.
q Unplug the LCD flexible cable from J2 on the FRONT unit
to separate the front panel.
w Unscrew 6 screws K (2 × 3.5 mm, silver) from the FRONT
unit.
e Unsolder the leads of speaker.
3-1
SECTION 4
CIRCUIT DESCRIPTION
The RF signals from the bandpass filter are mixed with the
1st LO signals, where come from the RX VCO circuit via the
attenuator (R360–R358), at the 1st mixer circuit (Q19) to
produce a 31.65 MHz 1st IF signal. The 1st IF signal is
passed through a monolithic filter (FI1) in order to obtain
selection capability and to pass only the desired signals. The
filtered signal is applied to the 2nd IF circuit after being
amplified at the 1st IF amplifier (Q18).
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
The antenna switching circuit functions as a low-pass filter
while receiving and a resonator circuit while transmitting.
This circuit does not allow transmit signals to enter the
receiver circuits.
Received signals enter the antenna connector (CHASSIS;
MP44) and pass through the low-pass filter (L1–L3, C1–C3,
C416–C419). The filtered signals are passed through the λ⁄4
type antenna switching circuit (D25, L39, D24) and then
applied to the RF circuit.
4-1-4 2ND IF AND DEMODULATOR CIRCUITS
The 2nd mixer circuit converts the 1st IF signal into a 2nd IF
signal. The double-conversion superheterodyne system
(which convert receive signals twice) improves the image
rejection ratio and obtains stable receiver gain.
4-1-2 RF CIRCUIT
The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals.
The 1st IF signal from the IF amplifier (Q18) is applied to the
2nd mixer section of the FM IF IC (IC3, pin 16), and is mixed
with the 2nd LO signal to be converted into a 450 kHz 2nd
IF signal.
The signals from the antenna switching circuit pass through
the two-stage tunable bandpass filters (D21, D20, L38, L37).
The filtered signals are amplified at the RF amplifier (Q20)
and then passed through the another two-stage tunable
bandpass filters (D19, D18, L36, L33) to suppress unwanted signals. The filtered signals are applied to the 1st mixer
circuit.
The FM IF IC (IC3) contains the 2nd mixer, 2nd local oscillator, limiter amplifier, quadrature detector, active filter and
noise amplifier circuits. A 2nd LO signal (31.2 MHz) is produced at the PLL circuit by doubling it’s reference frequency
(15.6 MHz).
D18–D21 employ varactor diodes, that are controlled by the
CPU via the D/A converter (IC27), to track the bandpass filter. These varactor diodes tune the center frequency of an
RF pass band for wide bandwidth receiving and good image
response rejection.
The 2nd IF signal from the 2nd mixer (IC3, pin 3) passes
through the ceramic filters (FI2, FI3) during narrow channel
spacing selection or FI2 only (bypassing FI3) during wide
channel spacing selection to remove unwanted heterodyned
frequencies. It is then amplified at the limiter amplifier section (IC3, pin 5) and applied to the quadrature detector section (IC3, pins 10, 11) to demodulate the 2nd IF signal into
AF signals.
4-1-3 1ST MIXER AND IST IF CIRCUITS
The 1st mixer circuit converts the received signal into fixed
frequency of the 1st IF signal with the PLL output frequency.
By changing the PLL frequency, only the desired frequency
passes through a cristal filter at the next stage of the 1st
mixer.
The demodulated AF signals are output from pin 9 (IC3) and
applied to the AF circuit via the receiver mute circuit.
• 2nd IF and demodulator circuits
2nd IF filter
450 kHz
23
Squelch level
controller (IC13)
FI3
8
24
7
Active
filter
31.2 MHz
FI2
3
5
Noise
detector
Doubler
2
X1
15.6 MHz
×2
Q15
Noise
comp.
Mixer
Limiter
amp.
FM
detector
RSSI
IC3 TA31136FN
9
10
12
11
AF signal "DSIN"
13
16
1st IF from the IF amplifier (Q18)
"NOIS" signal to the CPU (IC14, pin 75)
R5V
X2
4-1
"RSSI" signal to the CPU (IC14, pin 50)
A portion of the AF signals from the FM IF IC (IC3, pin 9)
passes through the low-pass filter (IC20b/a) to remove AF
(voice) signals and is applied to the CTCSS or DTCS
decoder inside of the CPU (IC14, pin 46) via the “RXDT” line
to control the AF mute switch via the I/O expander IC (IC23).
4-1-5 AF AMPLIFIER CIRCUIT
The AF amplifier circuit amplifies the demodulated AF signals to drive a speaker.
The AF signals from the FM IF IC (IC3, pin 9) are amplified
at the AF amplifier section of the compander IC (IC9, pins 5,
4) and are then applied to the high-pass filter circuit (IC7a).
4-2 TRANSMITTER CIRCUITS
The high-pass filter characteristics are controlled by the
FSW signal from the I/O expander IC (IC23, pin 14). When
FSW signal is high, the cut-off frequency is shifted higher to
remove CTCSS or DTCS signals.
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
The microphone amplifier circuit amplifies audio signals
within +6 dB/octave pre-emphasis characteristics from the
microphone to a level needed for the modulation circuit.
The filtered AF signals from the high-pass filter (IC7a, pin 1)
are applied to the de-emphasis section of compander IC
(IC9, pin 3) with frequency characteristics of –6 dB/octave,
and are then passed through the low-pass filter, high-pass
filter, expander sections of compander IC (IC9). The output
signal from IC9 (pin 38) is applied to the electronic volume
controller (IC13, pin 1).
The AF signals (MIC+) from the FRONT unit via J3 (pin 22)
are passed through the internal/extenal microphone switch
(IC19, pins 12, 14) and level controller (IC13, pins 9, 10) to
the microphone amplifier circuit.
The AF signals from the level controller (IC13) are applied to
the microphone amplifier section of compander IC (IC9, pin
12). The amplified signals are passed through the compressor, low-pass filter and high-pass filter sections of IC9.
The output AF signals from the electronic volume controller
(IC13, pin 2) are applied to the AF power amplifier (IC5) to
drive the speaker.
The filtered AF signals are amplified at the buffer amplifier
(Q47) and pre-emphasized with +6dB/octave at the preemphasis circuit (C203, R166), and are then applied to the
IDC amplifier section of IC9 (pin 8).
4-1-6 RECEIVE MUTE CIRCUITS
• NOISE SQUELCH
A squelch circuit cuts out AF signals when no RF signals are
received. By detecting noise components in the AF signals,
the squelch circuit switches the AF mute switch.
The amplified AF signals are passed through the limitter
amplifier and low-pass filter sections of IC9 after being
passed through the AF mute switch inside of IC9.
Some noise components in the AF signals from the FM IF IC
(IC3, pin 9) are passed through the level controller (IC13,
pins 24, 23). The level controlled signals are applied to the
active filter section in the FM IF IC (IC3, pin 8). Noise components about 10 kHz are amplified and output from pin 7.
The output signals from pin 6 are passed through the splatter filter (IC7c) and level controller (IC13, pins 21, 22), and
are then applied to the modulation circuit (D7).
The filtered signals are converted into the pulse-type signals
at the noise detector section and output from pin 13 (NOIS).
4-2-2 MODULATION CIRCUIT
The modulation circuit modulates the VCO oscillating signal
(RF signal) using the microphone audio signals.
The NOIS signal from the FM IF IC is applied to the CPU
(IC14, pin 75). Then the CPU analyzes the noise condition
and controls the AF mute signal via “AFMT” line (IC23, pin
13) to the AF regulator (Q23, Q24).
The AF signals from the level controller (IC13) change the
reactance of varactor diode (D7) to modulate the oscillated
signal at the TX VCO circuit (Q12, D8, D43–D45). The modulated VCO signal is amplified at the buffer amplifiers (Q8,
Q6) and is then applied to the drive amplifier circuit via the
T/R switch (D4).
• CTCSS AND DTCS
The tone squelch circuit detects AF signals and opens the
squelch only when receiving a signal containing a matching
subaudible tone (CTCSS or DTCS). When tone squelch is in
use, and a signal with a mismatched or no subaudible tone
is received, the tone squelch circuit mutes the AF signals
even when noise squelch is open.
The CTCSS/DTCS signals from the CPU (IC14, pin 44) are
passed through the low-pass filter (IC7d), level controller
(IC13, pins 12, 11) and mixer circuit (IC7b), and are then
applied to the VCO circuit via the splatter filter (IC7c).
• APC circuit
T5V
RF signal
from PLL
S5V
L5
to antenna
–
TMUT
Q22
T4
Q1
Power
amp.
Q2
Driver
amp.
D2
IC4
Power detector
circuit (D2)
+
APC control circuit
4-2
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
4-3 PLL CIRCUITS
The drive/power amplifier circuits amplify the VCO oscillating signal to an output power level.
4-3-1 PLL CIRCUIT
A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by
the divided ratio (N-data) of a programmable divider.
The signal from the VCO circuit passes through the T/R
switch (D4), and is amplified at the YGR (Q3), drive (Q2),
power (Q1) amplifiers to obtain 5 W of RF power (at 7.2 V
DC).
The PLL circuit contains the TX/RX VCO circuit (Q12, Q11).
The oscillated signal is amplified at the buffer amplifiers (Q8,
Q7) and then applied to the PLL IC (IC1, pin 5).
The amplified signal is passed through the APC detector,
antenna switching circuit (D1) and low-pass filter, and is
then applied to the antenna connector.
The PLL IC contains a prescaler, programmable counter,
programmable divider and phase detector, etc. The entered
signal is divided at the prescaler and programmable counter
section by the N-data ratio from the CPU. The divided signal
is detected on phase at the phase detector using the reference frequency.
The bias current of the drive (Q2) and power (Q1) amplifiers
is controlled by the APC circuit.
4-2-4 APC CIRCUIT
The APC circuit (IC4, Q22) protects the drive and power
amplifiers from excessive current drive, and selects output
power of HIGH, LOW2 or LOW1.
If the oscillated signal drifts, its phase changes from that of
the reference frequency, causing a lock voltage change to
compensate for the drift in the oscillated frequency.
The power detector circuit (D2) detects the transmit power
output level and converts it into DC voltage. The output voltage is at a minimum level when the antenna impedance is
matched at 50 Ω and is increased when it is mismatched.
4-3-2 VCO CIRCUIT
The VCO circuit contains a separate RX VCO (Q11, D6,
D40–D42) and TX VCO (Q12, D7, D8, D43–D45). The oscillated signal is amplified at the buffer amplifiers (Q8, Q6) and
is then applied to the T/R switch (D5, D4). Then the receive
1st LO (Rx) signal is applied to the 1st mixer (Q19) and the
transmit (Tx) signal to the YGR amplifier circuit (Q3).
The detected voltage is applied to the differential amplifier
(IC4, pin 3), and the “T4” signal from the D/A converter
(IC27, pin 4), controlled by the CPU (IC14), is applied to the
other input for reference. When antenna impedance is mismatched, the detected voltage exceeds the power setting
voltage. Then the output voltage of the differential amplifier
(IC4, pin 4) controls the input current of the drive amplifier
(Q2) and power amplifier (Q1) to reduce the output power.
A portion of the signal from the buffer amplifier (Q8) is fed
back to the PLL IC (IC1, pin 5) via the buffer amplifier (Q7)
as the comparison signal.
• PLL circuit
RX VCO
Buffer
Q6
Q11, D6, D40–D42
D4
Buffer
Q8
TX VCO
Buffer
Q7
Q12, D7, D8, D43–D45
Loop
filter
IC1 SA7025DK-T
14
Programmable
counter
Phase
detector
Programmable
divider
31.2 MHz signal
to the FM IF IC
Doubler
×2
Q15
Prescaler
Shift register
8
X1
15.6 MHz
4-3
D5
5
1
2
3
SCK
SO
PLST
to 1st mixer circuit
to transmitter circuit
4-4 POWER SUPPLY CIRCUIT
VOLTAGE LINE
LINE
HV
VCC
CPU5V
+5V
S5V
T5V
R5V
DESCRIPTION
Pin
number
Port
name
Description
35
SO
Outputs data signals for the PLL IC
(IC1), compamder IC (IC9), expander
IC (IC23), D/A converter (IC13), etc.
36
DAST
Outputs strobe signals to the D/A converter (IC13).
39
DTAC
Output clock signal to the DTMF
decoder (IC17).
43
SENC
Outputs single tone signal.
44
CTDA
Outputs CTCSS/DTCS tone signal.
45
SDEC
Single tone signal input port for decoding.
46
RXDT
CTCSS/DTCS signals input port for
decoding.
47
AFVI
Input port for the volume control [VOL].
High : [VOL] is maximum clockwise.
49
LVIN
Input port for the PLL lock voltage.
50
RSSI
Input port for the RSSI detection.
59
RES
Input port for the reset signal.
68
DTSD
Outputs serial data signals to the
DTMF decoder IC (IC17).
70
TMUT
Outputs transmit mute signal.
Low : During unlock or while muted
71
R5C
Outputs R5 regulator control signal.
Low: While receiving
The voltage from the attached battery pack.
The same voltage as the HV line (battery voltage) which is controlled by the power swtich
([VOL] control).
Common 5 V converted from the VCC line by the
reference regulator circuit (IC12). The output voltage is applied to the CPU (IC14), 5 V regulator circuit (Q32, Q33) and reset circuit (IC15), and etc.
Common 5 V converted from the VCC line by the
+5V regulator circuit (Q32, Q33).
Common 5 V converted from the +5V line by the
S5V regulator circuit (Q31).
5 V for transmitter circuits regulated by the T5V
regulator circuit (Q29).
5 V for receiver circuits regulated by the R5V
regulator circuit (Q30).
4-5 PORT ALLOCATIONS
4-5-1 CPU (IC14)
Pin
number
Port
name
Description
73
T5C
Outputs T5 regulator control signal.
Low: While transmitting
4
RESB
Outputs reset signal for the expader IC
(IC23).
75
NOIS
Input port for noise signals (pulsetype) for noise squelch operation.
5
RMUT
Input port for AF mute signal from the
optional units via J1 or J2.
81
SDA
I/O port for data signals from/to the
D/A converter (IC27).
6
MMUT
Input port for MIC mute signal from the
optional units via J1 or J2.
82
MSO
I/O port for data signals from/to
EEPROMs (IC16, IC24).
BEEP
Outputs beep audio signals.
PTOT
Input port for the [PTT] switch
Low : While [PTT] switch is pushed.
87
7
94
MSCK
Outputs clock signal to EEPROMs
(IC16, IC24).
EXST
Outputs strobe signals to the expander
IC (IC23).
95
SCL
Outputs clock signal to the D/A converter (IC27).
13
15
APST
Outputs strobe signals to the compander IC (IC9).
16
DIN
Outputs serial data signals to the compander IC (IC9).
17,
18,
19,
RGS1,
RGS2,
MSKE,
Output control signal for the compander IC (IC9).
Pin
number
Port
name
21
FCLR
Outputs reset signal for the compander IC (IC9).
4
BUSY
Outputs BUSY detection.
Low : The channel is busy.
22–
25
CB10–
CB13
Input ports for rotary selector [SEL].
6
DUSE
26
VCOS
Outputs TX VCO/RX VCO switching
signal for the VCO switch (Q9, Q10).
High : While transmitting
Outputs low-pass filter cut-off frequency control signal when DTCS is activated.
7
W/N
Outputs IF bandwidth control signal.
High : While IF bandwidth is narrow.
28
PLST
Outputs strobe signals to the PLL IC
(IC1).
11
S5C
Outputs S5 regulator control signal.
12
SPCN
Outputs internal speaker select signal.
29
ULCK
Input port for the PLL unlock signal.
Low : PLL is unlocked.
13
AFMT
34
SCK
Outputs clock signal for the PLL IC
(IC1), compamder IC (IC9), expander
IC (IC23), D/A converter (IC13), etc.
Outputs control signal for the AF
amplifier regulator circuit.
High: While AF amp. is activated.
14
FSW
Outputs high-pass filter’s characteristics select signal.
4-5-2 I/O EXPANDER (IC23)
4-4
Description
SECTION 5 ADJUSTMENT PROCEDURES
5-1 PREPARATION
When you adjust the contents on pages 5-5 and 5-6, SOFTWARE ADJUSTMENT, the optional CS-F30G ADJ ADJUSTMENT SOFT(Rev. 1.0 or later), *OPC-966 JIG CABLE (modified OPC-966 CLONING CABLE) are required.
WARE
■ REQUIRED TEST EQUIPMENT
EQUIPMENT
GRADE AND RANGE
EQUIPMENT
GRADE AND RANGE
DC power supply
Output voltage
Current capacity
: 7.5 V DC
: 5 A or more
Audio generator
Frequency range
Output level
: 300–3000 Hz
: 1–500 mV
FM deviation meter
Frequency range
Measuring range
: DC–300 MHz
: 0 to ±10 kHz
Attenuator
Power attenuation
Capacity
: 40 or 50 dB
: 10 W or more
Frequency counter
Frequency range
: 0.1–300 MHz
Frequency accuracy : ±1 ppm or better
Sensitivity
: 100 mV or better
Standard signal
generator (SSG)
Frequency range
Output level
: 100–300 MHz
: 0.1 µV–32 mV
(–127 to –17 dBm)
Digital multimeter
Input impedance
: 10 MΩ/V DC or better
DC voltmeter
Input impedance
: 50 kΩ/V DC or better
RF power meter
(terminated type)
Measuring range
Frequency range
Impedance
SWR
:
:
:
:
Oscilloscope
Frequency range
Measuring range
: DC–20 MHz
: 0.01–20 V
AC millivoltmeter
Measuring range
: 10 mV–10 V
1–10 W
100–300 MHz
50 Ω
Less than 1.2 : 1
■ SYSTEM REQUIREMENTS
• High power transmittion
When you adjust the output power (high power), the battery
type detector must be connected to GND (see illustration at
below). Otherwise the transceiver does not transmit high
power, the output power will be low.
• IBM PC compatible computer with an RS -232C serial port
(38400 bps or faster).
• Microsoft Windows 95 or Windows 98
• Intel i486DX processor or faster (Pentium 100 MHz or
faster recommended)
• At least 16 MB RAM and 10 MB of hard disk space
• 640×480 pixel display (800×600 pixel display recommended)
–
DC power supply
7.5 V/5.0 A
+
■ ADJUSTMENT SOFTWARE INSTALLATION
q Boot up Windows.
- Quit all applications when Windows is running.
w Insert the ‘CS-F30G’ into the appropriate drive.
e Select ‘Run’ from the [Start] menu.
r Type the setup program name using the full path name,
then push [Enter] key.
(ex. D:\CSF30GADJ\disk1\Setup.exe)
t Follow the prompts.
y Program group ‘CS-F30G ADJ’ appears in the ‘Programs’
folder of the [Start] menu.
■ STARTING SOFTWARE ADJUSTMENT
q Connect IC-F30GT, F30GS, F31GT or F31GS and PC
with *OPC-966 JIG CABLE.
w Turn the transceiver power ON.
e Boot up Windows, and click the program group ‘CS-F30G
ADJ’ in the ‘Programs’ folder of the [Start] menu, then
CS-F30G ADJ’s window appears.
r Click ‘Connect’ on the CS-F30G’s window, then appears
IC-F30GT, F30GS, F31GT or F31GS’s up-to-date condition.
t Set or modify adjustment data as desired.
Connect to GND
Battery type detector
IBM is a registered trademark of International Bussiness
Machines Corporation in the U.S.A. and other countries.
Microsoft and Windows are registered trademarks of
Microsoft Corporation in the U.S.A. and other countries.
Screen shots produced with permission from Microsoft
Corporation. All other products or brands are registered
trademarks or trademarks of their respective holders.
5-1
• Screen display exampe
CS-F30G ADJ Rev.1.0
File Option
COM 1: OPEN
2
Connect
Reload (F5)
Disp para
1
4
5
6
7
8
9
10
11
12
13
14
15
[A / D]
VIN
: 197 : C5h : 7.73 V
TEMPS : 190 : BEh : 32.23 'C
LVIN
: 67 : 43h : 1.31 V
SD
: 27 : 1Bh : 0.53 V
BDET :
0 : 00h : 0.00 V (Ni-Cd, Ni-MH)
CH No.
Power (Hi)
Power (L2)
Power (L1)
Ballance
MOD W
MOD N
CTCS/DTCS
SQL
BPF ALL
BPF T1
BPF T2
BPF T3
BPF T4
TXF
S-METER
[D / A]
BPF T1 :
BPF T2 :
BPF T3 :
T4/POW :
REF
:
MOD BAL :
Dev
:
CTCSS :
SQL Lev :
90
45
76
60
112
90
45
76
0
:
:
:
:
:
:
:
:
:
5Ah
2Dh
4Ch
3Ch
70h
5Ah
2Dh
4Ch
00h
:
:
:
:
:
:
:
:
:
1.76 V
0.88 V
1.49 V
1.18 V
2.20V
1.76 V
0.88 V
1.49 V
1.18 V
: 01 RX Freq = 155.000, TX Freq = <– RF Power: Low1 Mode: Wide
: 98 [ # # # # # # # # – – – – – – – – – – – ]
: 54 [ # # # # – – – – – – – – – – – – – – – ]
: 54 [ # # – – – – – – – – – – – – – – – – – ]
: 132 [ # # # # # # # # # # – – – – – – – – – ]
: 95 [ # # # # # # # – – – – – – – – – – – – ]
: 47 [ # # # # – – – – – – – – – – – – – – – ]
: 113 [ # # # # # # # # # – – – – – – – – – – ]
: 0 [–––––––––––––––––––]
: [Enter] to sweep
: 23 [ # # # # # # # # # # # # – – – – – – – ] [Enter] to sweep
: –22 [ # # # # # # # # – – – – – – – – – – – ] [Enter] to sweep
: 9 [ # # # # # # # # # # # – – – – – – – – ] [Enter] to sweep
: –7 [ # # # # # # # # # – – – – – – – – – – ] [Enter] to sweep
: [Enter] to start
: [Enter] to start
16
NOTE: The above values for settings are example only.
Each transceiver has its own specific values for each setting.
1 : Transceiver's connection state
9 : FM deviation
2 : Reload adjustment data
10 : CTCSS/DTCS deviation
3 : Receive sensitivity measurement
11 : Squelch level
4 : Connected DC voltage
12 : Receive sensitivity (automatically)
5 : PLL lock voltage
13 : Receive sensitivity (manually)
6 : Operating channel select
14 : Reference frequency
7 : RF output power
15 : S-meter
8 : Modulation balance
16 : Adjustment items
5-2
3
• Connection
to the antenna connector
FM
deviation meter
Attenuator
40 dB or 50 dB
Standard signal generator
0.1 µV to 32 mV
(–127 dBm to –17 dBm)
CAUTION:
DO NOT transmit while
SSG is connected to the
antenna connector.
RF power meter
0.1–10 W/50 Ω
Frequency
counter
Personal
computer
to an RS-232C port
Audio generator
DB9 female plug
(incl. level converter circuit)
SINAD meter
*OPC-966
(JIG CABLE)
RS-232C cable (straight)
Speaker (8 Ω)
• *OPC-966 (JIG CABLE)
Add a jumper wire here
OPC-966
(Cloning cable)
Electrolytic capacity
47 µF
PTTE
PTT
MIC
MICE
+
Audio generator
300 Hz to 3 kHz
AC
millivoltmeter
SP–
SP+
–
+
5-3
5-2 PLL ADJUSTMENT
MEASUREMENT
ADJUSTMENT
ADJUSTMENT CONDITIONS
UNIT
PLL LOCK
VOLTAGE
1 • Operating freq. : 136.000 MHz
• Receiving
ADJUSTMENT
VALUE
LOCATION
MAIN Connect a digital multimeter or an oscilloscope to the check
point, “LV”.
2 • Transmitting
3 • Operating freq. : 174.000 MHz
• Receiving
UNIT ADJUST
1.2 V
C373
3.0–4.5 V
Verify
• MAIN unit
C372
PLL lock voltage
adjustment for RX
LV
PLL lock voltage
check point
5-4
C372
1.0 V
4 • Transmitting
C373
PLL lock voltage
adjustment for TX
MAIN
5-3 SOFTWARE ADJUSTMENT
Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.
ADJUSTMENT
ADJUSTMENT CONDITION
MEASUREMENT
UNIT
LOCATION
VALUE
REFERENCE
FREQUENCY
[TXF]
1 • Operating freq. : 174.000 MHz
Top Loosely couple a frequnecy 174.0000 MHz
• Output power
: Low1
panel counter to the antenna connec• Connect an RF power meter or 50 Ω
tor.
dummy load to the antenna connector.
• Transmitting
OUTPUT
POWER
[Power (Hi)]
1 • Operating freq. : 136.000 MHz
• Output power
: High
• Transmitting
[Power (L2)]
2 • Output power
• Transmitting
: Low2
2.0 W
[Power (L1)]
3 • Output power
• Transmitting
: Low1
1.0 W
MODULATION
BALLANCE
[Ballance]
1 • Operating freq. : 155.000 MHz
• Output power
: Low1
• Set an FM deviation meter as:
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P–P)/2
• Push [P0] key while transmitting
FM
DEVIATION
[MOD W]
1 •
•
•
•
[MOD N]
2 • IF bandwidth
• Transmitting
CTCSS/DTCS
DEVIATON
[CTCS/DTCS]
1 • Operating freq. : 155.000 MHz
• Output power
: Low1
• IF bandwidth
: Wide
• CTCSS
: 88.5 Hz
• DTCS code
: 007
• No audio applied to the [MIC] input.
• Transmitting
Top Connect an RF power meter to
panel the antenna connector.
Top Connect an FM deviation meter
panel with an oscilloscope to the
antenna connector through an
attenuator.
Operating freq. : 155.000 MHz
Top Connect an FM deviation meter
Output power
: Low1
panel to the antenna connector
IF bandwidth
: Wide
through the attenuator.
Set the FM deviation meter as:
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P–P)/2
• Connect the audio generator to the multi
connector through the JIG cable (*OPC966) and set as : 1.0 kHz/150 mVrms
• Transmitting
: Narrow
5.0 W
Set to square wave
form
±4.1 kHz
±2.1 kHz
Top Connect an FM deviation meter
panel to the antenna connector
through the attenuator.
5-5
0.7 kHz
SOFTWARE ADJUSTMENT – continued
Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.
ADJUSTMENT
RX
SENSITIVITY
[BPF T1] –
[BPF T4]
MEASUREMENT
ADJUSTMENT CONDITION
UNIT
VALUE
LOCATION
1 • Operating freq. : 136.000 MHz
MAIN Connect a SINAD meter with an Minimum distortion
level
• IF bandwidth
: Wide
8 Ω load to the multi connector
• Connect a standard signal generator to
through the JIG cable (*OPCthe antenna connector and set as:
966).
Frequency
: 136.000 MHz
Level
: 10 µV* (–87 dBm)
Modulation
: 1 kHz
Deviation
: ±3.5 kHz
• Receiving
CONVENIENT:
The BPF T1–BPF T4 can be adjusted automatically.
q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER] key.
q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.
or
w-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.
w-2: Push [ENTER] key to start tuning.
w-3: Repeat w-1 and w-2 to perform additional BPF tuning.
S-METER
[S-METER]
SQUELCH
LEVEL
[SQL]
MAIN
1 • Operating freq. : 136.000 MHz
• IF bandwidth
: Wide
• Connect an SSG to the antenna connector and set as:
Frequency
: 136.000 MHz
Level
: 14 µV* (–84 dBm)
Modulation
: 1 kHz
Deviation
: ±3.5 kHz
• Receiving
Push [ENTER] key
on the connected
computer keyboard
to set “S3 level”.
2 • Set an SSG as
Level
Modulation
Deviation
• Receiving
Push [ENTER] key
on the connected
computer keyboard
to set “S1 level”.
:
: 0.45 µV* (–114 dBm)
: 1 kHz
: ±3.5 kHz
Front Internal speaker
1 • Operating freq. : 155.000 MHz
panel
• IF bandwidth
: Wide
• Connect an SSG to the antenna connector and set as:
Frequency
: 155.000 MHz
Level
: 0.2 µV* (–121 dBm)
Modulation
: 1 kHz
Deviation
: ±3.5 kHz
• Receiving
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
5-6
Set “SQL level” to
close squelch.
Then set “SQL level”
at the point where
the audio signals
just appears.
SECTION 6
PARTS LIST
[FRONT UNIT]
REF
NO.
[FRONT UNIT]
ORDER
NO.
REF
NO.
DESCRIPTION
ORDER
NO.
DESCRIPTION
IC1
IC2
1130009860 S.IC
1110002750 S.IC
TC74VHC373FT (EL)
TA75S01F (TE85R)
J1
J2
6510022360 S.CONNECTOR
6510022200 S.CONNECTOR
26FLZ-SM1-TB
40FLZ-SM1-R-TB
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
Q9
1530002850
1530002850
1590002150
1590002150
1590002150
1560001130
1560001130
1530002060
1590000430
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.FET
S.FET
S.TRANSISTOR
S.TRANSISTOR
2SC4116-BL (TE85R)
2SC4116-BL (TE85R)
DTC144TE TL
DTC144TE TL
DTC144TE TL
CPH3403-TL
CPH3403-TL
2SC4081 T106 R
DTC144EUA T106
D1
D2
D3
D4
1790001280
1790001280
1790001200
1790001280
S.DIODE
S.DIODE
S.DIODE
S.DIODE
MA111 (TX)
MA111 (TX)
MA6S121 (TX)
MA111 (TX)
DS1
DS2
DS3
DS4
DS5
DS6
DS7
DS8
DS9
DS10
DS11
DS12
DS13
DS14
DS15
5010000160
5010000160
5010000160
5010000160
5040002170
5010000120
5010000120
5010000120
5010000120
5030001870
5010000120
5010000120
5010000160
5010000120
5010000120
LNJ310M6URA
LNJ310M6URA
LNJ310M6URA
LNJ310M6URA
LNJ210C6ARA
LN1371G-(TR)
LN1371G-(TR)
LN1371G-(TR)
LN1371G-(TR)
EDMMUD1FA0
LN1371G-(TR)
LN1371G-(TR)
LNJ310M6URA
LN1371G-(TR)
LN1371G-(TR)
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R17
R18
R20
R21
R22
R23
R24
R25
R26
R27
7030007300
7030005030
7030007250
7030009150
7030009150
7030006610
7030008310
7030008370
7030004990
7030005030
7030007300
7030005060
7030007280
7030005090
7030005090
7410000750
7030005170
7030005090
7030005170
7030005050
7030005240
7030008300
7030007340
7030008010
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 220 X (22 Ω)
ERJ2GEJ 824 X (820 kΩ)
ERJ2GEJ 824 X (820 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 564 X (560 kΩ)
ERJ2GEJ 561 X (560 Ω)
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 331 X (330 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
EXB-V4V 104JV (100 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 123 X (12 kΩ)
MC1
7700002310 MICROPHONE
EM-140
S1
S2
S3
S4
S5
2230001060
2230001060
2230001060
2230001060
2230001060
EVQ-PUL 02K
EVQ-PUL 02K
EVQ-PUL 02K
EVQ-PUL 02K
EVQ-PUL 02K
SP1*
2510001060 SPEAKER
K036NA500-47
W1
W3
7120000470 JUMPER
7030003860 S.JUMPER
ERDS2T0
ERJ3GE JPW V
EP1
0910055257 PCB
B 5489G
C1
C2
C3
C4*
C6*
C7*
C8*
C9*
C10*
C11*
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21*
C22
C23*
C24
C25
C26
C27
C28
C29
C30
4030016930
4030016930
4030016930
4550006150
4550006150
4550006150
4550006150
4550006150
4550006150
4550006150
4030014180
4030014180
4030014180
4030014180
4030013850
4030014180
4030014180
4030016930
4030014180
4550006150
4030016930
4550006150
4030016790
4030014180
4030016930
4030017230
4030016790
4030013850
4030016930
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECST1CY105R
ECST1CY105R
ECST1CY105R
ECST1CY105R
ECST1CY105R
ECST1CY105R
ECST1CY105R
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1H470JCQ
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1H470JCQ
ECST1CY105R
ECJ0EB1A104K
ECST1CY105R
ECJ0EB1C103K
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1E271KBQ
ECJ0EB1C103K
ECUE1E102KBQ
ECJ0EB1A104K
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
LCD
S.LED
S.LED
S.LED
S.LED
S.LED
S.SWITCH
S.SWITCH
S.SWITCH
S.SWITCH
S.SWITCH
*=Safety critical components
6-1
[GT]
[GT]
[GT]
[GT]
[GT]
[GT]
[GS]
[GS]
S.=Surface mount
[MAIN UNIT]
REF
NO.
ORDER
NO.
IC1
IC2
IC3
IC4
IC5
IC7
IC9
IC12
IC13
IC14
IC15
IC16
IC17
IC18
IC19
IC20
IC23
IC24
IC27
IC29
IC30
IC31
1130009130
1130008560
1110003490
1130008560
1110001810
1110003780
1130009330
1110003390
1190001350
1140010140
1110005770
1140008650
1130009700
1110002750
1130008230
1110003800
1130007570
1140008650
1190001340
1130008230
1130007020
1130008560
[MAIN UNIT]
REF
NO.
DESCRIPTION
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
SA7025DK-T
TC75S51F (TE85L)
TA31136FN (D, EL)
TC75S51F (TE85L)
TA7368F (TP1)
NJM2902V-TE1
TC35453F (BR, DRY)
AN8005M-(E1)
M62364FP 600D
HD64F2238BFA13
S-80942CNMC-G9C-T2
HN58X2464TI
LC73872M-TRM
TA75S01F (TE85R)
BU4053BCFV-E2
NJM2904V-TE1
BU4094BCFV-E2
HN58X2464TI
M62334FP 600C
BU4053BCFV-E2
TC7S66FU (TE85R)
TC75S51F (TE85L)
Q1
Q2
Q3
Q6
Q7
Q8
Q9
Q10
Q11
Q12
Q13
Q14
Q15
Q16
Q17
Q18
Q19
Q20
Q21
Q22
Q23
Q24
Q26
Q27
Q29
Q30
Q31
Q32
Q33
Q39
Q40
Q41
Q43
Q44
Q45
Q46
Q47
1560001050
1560001020
1530002920
1530002600
1530002600
1530002600
1590000430
1590001400
1530002920
1530002920
1590001190
1560000540
1530002690
1590000720
1530002690
1530002600
1580000430
1580000730
1560000840
1590000720
1520000460
1590001190
1590000430
1530003090
1510000580
1510000580
1510000580
1520000460
1590001190
1530002690
1590001400
1590000430
1530002690
1590000430
1590002530
1590000430
1530002690
S.FET
S.FET
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.FET
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.FET
S.FET
S.FET
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
2SK2974
2SK2973 (MTS101P)
2SC4226-T1 R25
2SC4215-O (TE85R)
2SC4215-O (TE85R)
2SC4215-O (TE85R)
DTC144EUA T106
XP1214 (TX)
2SC4226-T1 R25
2SC4226-T1 R25
XP6501-(TX) .AB
2SK880-Y (TE85R)
2SC4116-GR (TE85R)
DTA144EUA T106
2SC4116-GR (TE85R)
2SC4215-O (TE85R)
3SK206-T1 U78
3SK293 (TE85L)
2SK1829 (TE85R)
DTA144EUA T106
2SB1132 T100 R
XP6501-(TX) .AB
DTC144EUA T106
2SC4213-B (TE85R)
2SA1362-GR (TE85R)
2SA1362-GR (TE85R)
2SA1362-GR (TE85R)
2SB1132 T100 R
XP6501-(TX) .AB
2SC4116-GR (TE85R)
XP1214 (TX)
DTC144EUA T106
2SC4116-GR (TE85R)
DTC144EUA T106
UN911H (TX)
DTC144EUA T106
2SC4116-GR (TE85R)
D1
D2
D4
D5
D6
D7
D8
D10
D13
D14
D15
D16
D18
D19
D20
D21
D22
D23
D24
1790000620
1790000650
1790000620
1790000620
1750000710
1720000400
1750000710
1160000060
1160000050
1160000050
1160000060
1160000060
1750000710
1750000710
1750000710
1750000710
1790001250
1790001250
1790000620
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.VARICAP
S.VARICAP
S.VARICAP
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.VARICAP
S.VARICAP
S.VARICAP
S.VARICAP
S.DIODE
S.DIODE
S.DIODE
MA77 (TX)
MA713 (TX)
MA77 (TX)
MA77 (TX)
HVC350BTRF
1SV245 (TPH3)
HVC350BTRF
DAN202U T106
DAP202U T106
DAP202U T106
DAN202U T106
DAN202U T106
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
MA2S111-(TX)
MA2S111-(TX)
MA77 (TX)
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
ORDER
NO.
DESCRIPTION
D25
D26
D27
D29
D30
D31
D33
D34
D35
D36
D38
D39
D40
D41
D42
D43
D44
D45
D46
D47
1790000620
1790001250
1790000620
1790001250
1730002360
1790001250
1790001250
1790000950
1790000950
1790000950
1790001250
1730002260
1750000710
1750000710
1750000710
1750000710
1750000710
1750000710
1790000980
1730002270
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.ZENER
S.DIODE
S.DIODE
S.ZENER
S.ZENER
S.ZENER
S.DIODE
S.ZENER
S.VARICAP
S.VARICAP
S.VARICAP
S.VARICAP
S.VARICAP
S.VARICAP
S.DIODE
S.ZENER
MA77 (TX)
MA2S111-(TX)
MA77 (TX)
MA2S111-(TX)
MA8062-M (TX)
MA2S111-(TX)
MA2S111-(TX)
MA8056-M (TX)
MA8056-M (TX)
MA8056-M (TX)
MA2S111-(TX)
MA8030-H (TX)
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
MA742 (TX)
MA8024 (TX)
FI1
FI2
FI3
FI4
2010002510
2020001490
2020001080
2040001440
S.XTAL
S.CERAMIC
S.CERAMIC
S.LC
FL-322 (31.650 MHz)
SFPCA450KE4A-R1
SFPCA450KG1A-R1
NFE31PT152Z1E9L
X1
X2
X3
X4
6050010960
6070000190
6050011000
6050009910
S.XTAL
S.DISCRIMINATOR
S.XTAL
S.XTAL
CR-667 (15.600 MHz)
CDBCB450KCAY24-R0
CR-681 (12.288 MHz)
CR-563 (3.579545 MHz)
L1
L2
L3
L4
L5
L7
L8
L9
L10
L13
L14
L15
L17
L18
L19
L20
L21
L22
L23
L24
L25
L26
L27
L28
L29
L31
L33
L35
L36
L37
L38
L39
L40
L41
L42
L43
L44
L45
L46
L47
L48
L49
L50
L51
L52
L53
6200008580
6200008150
6200008280
6200002960
6200008280
6200008490
6200008330
6200003590
6200009450
6200007690
6200003590
6200005690
6200006980
6200006980
6200007170
6200008190
6200005540
6200004950
6200008390
6200005540
6200004950
6200004950
6200004950
6200004950
6200005720
6200002790
6200007750
6200001980
6200007750
6200007750
6200007750
6200009290
6200009290
6200003590
6200004950
6200002860
6200001980
6200004660
6200007170
6200001980
6200009460
6200008390
6200006980
6200002150
6200006980
6200003960
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
0.30-1.4-6TL 32N
0.35-1.6-7TL 44N
0.30-1.7-7TL 50N
NL 322522T-4R7J-3
0.30-1.7-7TL 50N
0.30-0.9-3TR 7.5N
0.45-1.4-4TL 15N
EXCCL3225U1
0.20-1.0-6TL 25N
LQW2BHN18NJ01L
EXCCL3225U1
ELJRE 18NG-F
ELJRE R10G-F
ELJRE R10G-F
MLF1608A 3R3K-T
0.25-1.9-8TL 80N
ELJNC R47K-F
NL 252018T-1R8J
0.25-1.9-9TL
ELJNC R47K-F
NL 252018T-1R8J
NL 252018T-1R8J
NL 252018T-1R8J
NL 252018T-1R8J
ELJRE 33NG-F
ELJFC R82M-F
LQW2BHN56NJ01L
NL 252018T-1R0J
LQW2BHN56NJ01L
LQW2BHN56NJ01L
LQW2BHN56NJ01L
LQW18AN47NG00D
LQW18AN47NG00D
EXCCL3225U1
NL 252018T-1R8J
NL 252018T-4R7J
NL 252018T-1R0J
MLF1608A 1R8K-T
MLF1608A 3R3K-T
NL 252018T-1R0J
0.25-1.9-7TL 67N
0.25-1.9-9TL
ELJRE R10G-F
ELJNC 56NK-F
ELJRE R10G-F
MLF1608A 1R0K-T
*=Safety critical components
6-2
S.=Surface mount
[MAIN UNIT]
REF
NO.
R1
R2
R3
R4
R5
R6
R7
R8
R10
R12
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
R26
R28
R29
R30
R31
R32
R33
R34
R35
R36
R37
R38
R39
R40
R41
R42
R43
R44
R45
R46
R47
R48
R49
R50
R51
R52
R53
R54
R55
R57
R58
R59
R60
R61
R62
R63
R64
R65
R66
R67
R69
R73
R75
R77
R78
R79
R80
R81
R82
R85
R86
R87
R88
R89
R90
[MAIN UNIT]
ORDER
NO.
7030003670
7030000280
7030003480
7030003480
7030005040
7030005040
7030003240
7030008290
7030005590
7030005050
7030005530
7030007570
7030005590
7030007570
7030004980
7030005050
7030005120
7030004980
7030005240
7030009320
7030004990
7030005070
7030004980
7030005070
7030005050
7030008400
7030008410
7030007250
7030007280
7030008400
7030008410
7030005530
7030009280
7030007290
7030005530
7030004980
7030005530
7030005110
7030005090
7030009270
7030005030
7030005290
7030005040
7030005530
7030005040
7030008010
7030005050
7030009710
7030005050
7030005290
7030005120
7030005050
7030004980
7030005110
7030004980
7030005220
7030009700
7410000950
7030009700
7030005090
7030005110
7030007570
7030005580
7030005240
7030005240
7030005240
7030005090
7030005090
7030005090
7030005090
7030007340
7030005220
7030008010
7030005220
7030009320
7030007340
7030007280
7030005080
7030008410
7030005240
7030005030
7030004970
DESCRIPTION
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
ERJ3GEYJ 823 V (82 kΩ)
MCR10EZHJ 150 Ω (151)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ3GEYJ 220 V (22 Ω)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 680 X (68 Ω)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 122X (1.2 kΩ)
ERJ2GEJ 680 X (68 Ω)
ERJ2GEJ 122X (1.2 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 182 X (1.8 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 220 X (22 Ω)
ERJ2GEJ 331 X (330 Ω)
ERJ2GEJ 182 X (1.8 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GE 391 X (390 Ω)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 101 X (100 Ω) [F30G]
ERJ2GEJ 100 X (10 Ω) [F31G]
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 821 X (820 Ω) [F30G]
ERJ2GEJ 152 X (1.5 kΩ) [F31G]
ERJ2GEJ 682 X (6.8 kΩ) [F30G]
ERJ2GEJ 472 X (4.7 kΩ) [F31G]
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 472 X (4.7 kΩ) [F30G]
ERJ2GEJ 123 X (12 kΩ) [F31G]
ERJ2GEJ 103 X (10 kΩ) [F30G]
ERJ2GEJ 203 X (20 kΩ) [F31G]
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 682 X (6.8 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 202 X (2 kΩ)
EXB-V8V 102JV
ERJ2GEJ 202 X (2 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 122X (1.2 kΩ)
ERJ2GEJ 560 X (56 Ω)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 331 X (330 Ω)
ERJ2GEJ 823 X (82 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 470 X (47 Ω)
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
REF
NO.
ORDER
NO.
R91
R92
R93
R94
R95
R96
R97
R98
R99
R102
R103
R105
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
R122
R123
R124
R125
R126
R127
R128
R129
R130
R131
R132
R133
R134
R135
R136
R137
R138
R139
R140
R141
R150
R151
R152
R153
R155
R157
R159
R161
R162
R163
R164
R165
R166
R167
R168
R171
R172
R173
R174
R175
R176
R177
R178
R179
R180
R181
R182
R183
R184
R185
R186
R187
R188
R189
R190
R192
R193
7030005050
7030005240
7030005240
7030007300
7030009320
7030008410
7030005010
7030005090
7030005120
7030008280
7030004990
7030005040
7030004980
7030005040
7030005100
7030005050
7030005110
7030005050
7030005050
7030005090
7030008280
7030005090
7030006610
7030007340
7030009320
7030008400
7030005240
7030005170
7030005050
7030005090
7030004980
7030005090
7030008410
7030005050
7030005230
7030008300
7030007290
7030003200
7030003200
7030005290
7030009140
7030007300
7030005120
7030005160
7030005070
7030005110
7030005100
7030005100
7030009320
7030007350
7030005220
7030005090
7030005070
7030005070
7030005060
7030005110
7030005240
7030005050
7030005170
7030007350
7030005070
7030005070
7030005100
7030005600
7030009290
7030005720
7030008290
7030005600
7030005600
7030007340
7030005600
7030005600
7030005030
7030008010
7030005310
7030005070
7030005040
7030005090
7030005000
7030005090
7030005090
7210003060
DESCRIPTION
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
VARIABLE
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 271 X (270 Ω)
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 271 X (270 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 182 X (1.8 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 334 X (330 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ3GEYJ 100 V (10 Ω)
ERJ3GEYJ 100 V (10 Ω)
ERJ2GEJ 682 X (6.8 kΩ)
ERJ2GEJ 272 X (2.7 kΩ)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 105 X (1 MΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 393 X (39 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 393 X (39 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 563 X (56 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 124 X (120 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
TP76N00N-15F-10KA-2251
*=Safety critical components
6-3
S.=Surface mount
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
R195
R196
R197
R198
R199
R200
R201
R202
R203
R206
R207
R208
R209
R210
R211
R212
R215
R216
7030005040
7030005050
7030005040
7030005050
7030005040
7030005050
7030007290
7030005120
7030005050
7030004980
7030005220
7030007340
7030005230
7030006610
7030007570
7030003830
7030005160
7030005090
7030005090
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
R217
R218
R219
R220
R221
R222
R223
R224
R225
R226
R227
R228
R229
R230
R231
R232
R233
R234
R235
R236
R237
R238
R239
R240
R242
R243
R244
R245
R246
R247
R248
R249
R250
R251
R252
R253
R254
R257
R258
R259
R260
R261
R262
R264
R266
R267
R268
R269
R270
R271
R272
R273
R274
R275
R276
R277
R278
R279
R280
R281
R284
R285
7030005000
7030007350
7030005050
7030005090
7030005060
7030005090
7410000580
7030005090
7030005090
7510001470
7030005090
7030010080
7030010080
7030008010
7030008010
7030008010
7030005090
7030005050
7030005120
7410000950
7410000950
7410000950
7410000950
7410000770
7410000700
7410000900
7410000950
7410000770
7410000950
7410000950
7030005120
7410000950
7410000950
7410000950
7410000950
7410000750
7030008300
7030005220
7030005220
7030005240
7030005240
7030005240
7030009290
7030005000
7030005240
7030005240
7030004980
7030005310
7030008290
7030005110
7030005070
7030005220
7030005220
7030005220
7030004970
7030005120
7030005120
7030005120
7030005120
7030005600
7030005120
7030005050
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.THERMISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.RESISTOR
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
DESCRIPTION
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 334 X (330 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 122X (1.2 kΩ)
ERJ3GEYJ 185 V (1.8 MΩ)
ERJ2GEJ 105 X (1 MΩ)
[GT]
ERJ2GEJ 104 X (100 kΩ) [GS]
ERJ2GEJ 104 X (100 kΩ)
[GT] only
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 393 X (39 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 104 X (100 kΩ)
EXB-V4V 224JV (220 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
NTCG20 4AG 473JT
ERJ2GEJ 104 X (100 kΩ)
ERJ2RHD 104 X (100 kΩ)
ERJ2RHD 104 X (100 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 102 X (1 kΩ)
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V4V 102JV (1 kΩ)
EXB-V8V 105JV (1 MΩ)
EXB-V4V 105JV (1 MΩ)
EXB-V8V 102JV
EXB-V4V 102JV (1 kΩ)
EXB-V8V 102JV
EXB-V8V 102JV
ERJ2GEJ 102 X (1 kΩ)
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V8V 102JV
EXB-V4V 104JV (100 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 124 X (120 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 470 X (47 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
REF
NO.
ORDER
NO.
R288
R289
R291
R292
R293
R294
R295
R296
R297
R298
R299
R307
R312
R313
R314
R315
R316
R317
R318
R321
R322
R323
R324
R325
R327
R328
R329
R330
R331
R332
R333
R334
R336
R340
R341
R342
R343
R344
R345
R347
R349
R352
R354
R355
R356
R358
R359
R360
R361
R362
R363
R364
R365
R366
R367
R368
R369
R370
R371
R372
R373
R374
R375
R376
7030005050
7030005090
7030005090
7030009290
7030005090
7030005240
7030005240
7030005240
7410000950
7030005090
7030005120
7030005090
7030005220
7030005060
7030005060
7030005060
7030009140
7030005170
7030005060
7030007290
7410000710
7030005090
7030005000
7030005050
7030004970
7030005120
7030005050
7030009320
7030005170
7030005090
7030005120
7030005040
7030005090
7030008300
7030005600
7030005120
7410000770
7030005120
7030005120
7030009320
7030005120
7030005050
7030008410
7030005240
7030008300
7030003210
7030005000
7030005000
7030005000
7030009290
7030005090
7030005090
7030007350
7030005080
7030005030
7030006610
7030008300
7030005240
7030005220
7030005060
7030005040
7030005240
7030005040
7030005120
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.ARRAY
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
EXB-V8V 102JV
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 272 X (2.7 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
EXB-V8V 224JV (220 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 470 X (47 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 102 X (1 kΩ)
EXB-V4V 102JV (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ3GEYJ 120 V (12 Ω)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 393 X (39 kΩ)
ERJ2GEJ 823 X (82 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 102 X (1 kΩ)
C1
C2
C3
C4
C5
C6
C7
C8
C9
C12
C14
C16*
C17
C18
C19
C20
4030007070
4030007070
4030007040
4030006860
4030013850
4030013850
4030014180
4030006860
4030007050
4030007050
4030007100
4030008680
4030013850
4030013850
4030007150
4030013850
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
C1608 CH 1H 330J-T
C1608 CH 1H 330J-T
C1608 CH 1H 180J-T
C1608 JB 1H 102K-T
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H470JCQ
C1608 JB 1H 102K-T
C1608 CH 1H 220J-T
C1608 CH 1H 220J-T
C1608 CH 1H 560J-T
C2012 JF 1C 105Z-T
ECUE1E102KBQ
ECUE1E102KBQ
C1608 CH 1H 151J-T
ECUE1E102KBQ
DESCRIPTION
*=Safety critical components
6-4
S.=Surface mount
[MAIN UNIT]
REF
NO.
ORDER
NO.
C21
C22
C23*
C24
C26
C27
C28
C29
C30
C31
C34
C35
C36
C37
C38
C39
C42
C43
C46
C47
C48
C49
C50
C51
C52
C53
C54
C55
C56
C57
C58
C59
C61
C62*
C63*
C64
C65
C66
C67
C68
C69
C70
C71
C72
C73
C74
C76
C77
4030014220
4030013850
4550006660
4030014220
4030013850
4030013850
4030014180
4030013850
4030016930
4030016930
4030006860
4030013850
4030014180
4030013850
4030013850
4030014240
4030013850
4030013850
4030014240
4030013850
4030014100
4030014130
4030014020
4030013850
4030013850
4030014180
4030014220
4030016790
4030016820
4030014130
4030014130
4030007090
4030014150
4550006700
4550006700
4030013850
4030014220
4030014420
4030014130
4030014240
4030007050
4030014070
4030016820
4030014440
4030014180
4550006810
4030007130
4550006360
4550006130
4030013850
4030016930
4030013850
4030016930
4030014180
4030014120
4030016790
4030014130
4030014030
4030014080
4030014050
4030013850
4030014140
4030014140
4030014180
4030014180
4030014180
4030014180
4030016790
4030014180
4030013850
4030013850
4030016760
4030014120
4030016930
4030013850
4030016930
4030014180
4030014180
4030016930
4030016930
4030014330
4030014330
C78
C79
C80
C81
C82
C83
C84
C85
C86
C87
C88
C89
C90
C91
C95
C96
C97
C98
C99
C100
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
[MAIN UNIT]
DESCRIPTION
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
ECUE1E471KBQ
ECUE1E102KBQ
ECST1CC226R
ECUE1E471KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H470JCQ
ECUE1E102KBQ
ECJ0EB1A104K
ECJ0EB1A104K
C1608 JB 1H 102K-T
ECUE1E102KBQ
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H180JCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H180JCQ
ECUE1E102KBQ
ECUE1H070CCQ
ECUE1H120JCQ
ECUE1H020BCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H470JCQ
ECUE1E471KBQ
ECJ0EB1C103K
ECUE1HR75BCQ
ECUE1H120JCQ
ECUE1H120JCQ
C1608 CH 1H 470J-T
ECUE1H220JCQ
ECST1AY106R
ECST1AY106R
ECUE1E102KBQ
ECUE1E471KBQ
ECUE1H0R5BCQ
ECUE1H120JCQ
ECUE1H180JCQ
C1608 CH 1H 220J-T
ECUE1H040BCQ
ECUE1HR75BCQ
ECUE1H820JCQ
ECUE1H470JCQ
ECST1VY473R
C1608 CH 1H 101J-T
ECST1VY104R
ECST1VY224R
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H100CCQ
ECJ0EB1C103K
ECUE1H120JCQ
ECUE1H2R5BCQ
ECUE1H050BCQ
ECUE1H030BCQ
ECUE1E102KBQ
ECUE1H150JCQ
ECUE1H150JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECJ0EB1C103K
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E472KBQ
ECUE1H100CCQ
ECJ0EB1A104K
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1H221JCQ
ECUE1H221JCQ
[F30G]
[F31G]
[F30G]
[F31G]
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
REF
NO.
ORDER
NO.
C113
C114
C115
C116
C117
C118
C119
C120
C121
C122
C123
C124*
C125
C126
C127*
C128
C130
C131
C132
C133
C134
C135
C137
C138
C139
C140
C141
C142
C143
C145
C146
C147
C148
C149
C150
C151
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C165
C167
C168
C170
C171
C172*
C173
C174
C175
C176
C177
C178*
C179
C180
C181*
C182
C183
C184*
C185
C186
C187
C188
C189
C192
C193*
C195
C197
C198
C199
C200
C202
C203
C205
C206
C207
C208*
4030016790
4030016930
4030013850
4030014220
4030013850
4030013850
4030013850
4030013850
4030016930
4030014180
4030014200
4550006700
4030014200
4030014220
4550006170
4030014100
4030013850
4030014160
4030016790
4030013850
4030013850
4030014080
4030014090
4030013850
4030013850
4030014000
4030013850
4030013850
4030014100
4030013850
4030013850
4030013850
4030013850
4030014220
4030014180
4030013850
4030014180
4030013850
4030014080
4550006140
4030014180
4030013850
4030014100
4030013850
4030013850
4030013980
4030014070
4030014090
4030014110
4030007000
4030016790
4550006540
4030016790
4030013850
4030016930
4030013850
4030014220
4550006670
4030016950
4030014180
4550006700
4030016960
4030013850
4550006210
4030016930
4030016930
4030014180
4030014180
4030013850
4030016760
4550006620
4030014220
4030016790
4030016760
4030014500
4030014350
4030017230
4030016920
4550006360
4030016930
4030016930
4550006320
DESCRIPTION
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
ECJ0EB1C103K
ECJ0EB1A104K
ECUE1E102KBQ
ECUE1E471KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H101JCQ
ECST1AY106R
ECUE1H101JCQ
ECUE1E471KBQ
ECST1AY225R
ECUE1H070CCQ
ECUE1E102KBQ
ECUE1H270JCQ
ECJ0EB1C103K
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H050BCQ
ECUE1H060CCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H1R5BCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H070CCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E471KBQ
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1H050BCQ
ECST1EY474R
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1H070CCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H010BCQ
ECUE1H040BCQ
ECUE1H060CCQ
ECUE1H080CCQ
C1608 CH 1H 090D-T
ECJ0EB1C103K
ECST1CY475R
ECJ0EB1C103K
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1E102KBQ
ECUE1E471KBQ
ECST1AD107R
ECJ0EB1A473K
ECUE1H470JCQ
ECST1AY106R
ECJ0EB1C183K
ECUE1E102KBQ
ECST1CX106R
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1E472KBQ
ECST0JY226R
ECUE1E471KBQ
ECJ0EB1C103K
ECUE1E472KBQ
ECUE1H121JCQ
ECUE1H560JCQ
ECUE1E271KBQ
ECUE1H222KBQ
ECST1VY104R
ECJ0EB1A104K
ECJ0EB1A104K
ECST0JY475R
*=Safety critical components
6-5
S.=Surface mount
[MAIN UNIT]
REF
NO.
ORDER
NO.
C213*
C214
C215
C216
C217
C218
C219
C224
C225
C226
C227
C228
C229
C230*
C231
C232
C233
C234
C235*
C236*
C237*
C238*
C239
C240
C241
C242*
C243*
C244
C246
C247*
C248
C249
C250
C251*
C252
C253
C254*
C257
C258
C259
C260
C261
C262
C263
C264*
C265*
C266
C267
C268
C271
C272
C273
C275
C276
C277
C278
C279
C280
C281
C282
C283
C284
C285
C286
C287
C288
C289
C291
C292
C293
C294
C295
C296
C297
C298
C299
C300
C301
C302
C303
C304
C305
4550006320
4550006360
4030016930
4030016950
4030016930
4030016760
4030014500
4030016930
4030016950
4030016950
4030017040
4030014220
4030014180
4550006700
4030016760
4030016920
4030016930
4030014180
4550006620
4550006620
4550006620
4550006620
4030016790
4030016790
4030016790
4550006320
4550006950
4030013850
4030013850
4550006210
4030016960
4030016960
4030014220
4550006170
4030014220
4030013850
4550006320
4030016930
4030016930
4030016790
4030013850
4030016930
4030014220
4030016930
4550006950
4550006950
4030014220
4030016790
4030016930
4030017030
4030014180
4030014180
4030014180
4030014150
4030014100
4030016790
4030016790
4030014170
4030016930
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
[MAIN UNIT]
DESCRIPTION
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
ECST0JY475R
ECST1VY104R
ECJ0EB1A104K
ECJ0EB1A473K
ECJ0EB1A104K
ECUE1E472KBQ
ECUE1H121JCQ
ECJ0EB1A104K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A333K
ECUE1E471KBQ
ECUE1H470JCQ
ECST1AY106R
ECUE1E472KBQ
ECUE1H222KBQ
ECJ0EB1A104K
ECUE1H470JCQ
ECST0JY226R
ECST0JY226R
ECST0JY226R
ECST0JY226R
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECST0JY475R
ECST0JX476R
ECUE1E102KBQ
ECUE1E102KBQ
ECST1CX106R
ECJ0EB1C183K
ECJ0EB1C183K
ECUE1E471KBQ
ECST1AY225R
ECUE1E471KBQ
ECUE1E102KBQ
ECST0JY475R
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1C103K
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1E471KBQ
ECJ0EB1A104K
ECST0JX476R
ECST0JX476R
ECUE1E471KBQ
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EB1A273K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H220JCQ
ECUE1H070CCQ
ECJ0EB1C103K
ECJ0EB1C103K
ECUE1H330JCQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
REF
NO.
ORDER
NO.
C306
C307
C308
C309
C310
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
C345
C346
C347
C348
C349
C350
C351
C352
C353
C354
C355
C356
C357
4030016930
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030016760
4030016760
4030016790
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030016930
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014180
4030014430
4030016930
4030017250
4030016790
4030017040
4030016930
4030016930
4030017240
4030016790
4030016930
4030016940
4030013850
4030013850
4030013850
4030014180
4550006770
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
C358
C359
C360*
C362
C364
C365
C366
C367
C369
C371
C372
C373
C375
C376
C377
C378
C379
C380
C381
C382
C383
C384
C385
C386
C393*
C394
C395
C396*
C397
C398
4030014220
4030013850
4030012600
4030017220
4030014180
4030014180
4030014180
4030014180
4030014110
4030014180
4610001590
4610001590
4030016930
4030013850
4030014180
4030016930
4030014180
4030014180
4030014180
4030014180
4030016930
4030013850
4030016930
4030014180
4030012600
4030016960
4030014190
4030012600
4030016760
4030016760
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TRIMMER
S.TRIMMER
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
DESCRIPTION
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1E472KBQ
ECUE1E472KBQ
ECJ0EB1C103K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
C1005 JB 1C 153K-T-A
ECJ0EB1A104K
ECUE1E821KBQ
ECJ0EB1C103K
ECJ0EB1A333K
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1C682KBQ
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EB1A393K
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1H470JCQ
TEMSVD2 1C 476M-12R
except [IS]
ECUE1E471KBQ
except [IS]
ECUE1E102KBQ
except [IS]
C2012 JB 1A 105M-T
ECUE1E122KBQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H080CCQ
ECUE1H470JCQ
TZC3R100A110R00
TZC3R100A110R00
ECJ0EB1A104K
ECUE1E102KBQ
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1H470JCQ
C2012 JB 1A 105M-T
ECJ0EB1C183K
ECUE1H680JCQ
C2012 JB 1A 105M-T
ECUE1E472KBQ
ECUE1E472KBQ
*=Safety critical components
6-6
S.=Surface mount
[MAIN UNIT]
REF
NO.
ORDER
NO.
C399
C400
C401
C402*
C403
C404
C405
C406
C407
C408
C409
C410
C411*
C412
C413
C414
C415*
C416
C417
C418
C419
C420
C421
C422
C423
C424
C425
C426
C427*
C428
C429
C430
C431
C432
C433
C434
C437
C438
C439
C440
C441
C442*
C443
C444
C445
C446
C447
C448
C449
C450
C451
C452
C453
C454
C455
C456
C457
C458
4030016760
4030013850
4030014180
4550006950
4030006860
4030014180
4030014180
4030013940
4030016930
4030016930
4030016930
4030016930
4550006320
4030014180
4030016930
4030016930
4550006170
4030007010
4030007010
4030009920
4030009540
4030013850
4030016930
4030016930
4030016930
4030014220
4030013850
4030011810
4550006320
4030016930
4030014180
4030013850
4030013850
4030016930
4030014180
4030016930
4030014090
4030013850
4030013850
4030013850
4030007090
4550006320
4030013850
4030014490
4030013940
4030017250
4030017250
4030016950
4030016930
4030016930
4030014180
4030016930
4030014140
4030014240
4030016930
4030016930
4030014200
4030016930
J1
J2
J3
6510018430 S.CONNECTOR
6510018430 S.CONNECTOR
6510022360 S.CONNECTOR
AXN330C038P
AXN330C038P
26FLZ-SM1-TB
F1
5210000710 S.FUSE
KAB 2402 322 NA29
S1
2250000180 ENCODER
EC10SP16-47
W2
W3
W4
W5
7030003860
7030003860
7030003860
8900009790
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
OPC-972
EP1
0910055243 PCB
DESCRIPTION
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.JUMPER
S.JUMPER
S.JUMPER
CABLE
[GT]: IC-F30GT/F31GT,
[GS]: IC-F30GS/F31GS,
[F30G]: IC-F30GT/F30GS,
[F31G]: IC-F31GT/F31GS
[IS]: Intrinsically safe version
ECUE1E472KBQ
ECUE1E102KBQ
ECUE1H470JCQ
ECST0JX476R
C1608 JB 1H 102K-T
ECUE1H470JCQ
ECUE1H470JCQ
C1005 JB 1E 223K-T-N
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECST0JY475R
ECUE1H470JCQ
ECJ0EB1A104K
ECJ0EB1A104K
ECST1AY225R
C1608 CH 1H 100D-T
C1608 CH 1H 100D-T
C1608 CH 1H 050B-T
C1608 CH 1H 1R5B-T
ECUE1E102KBQ
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1E471KBQ
ECUE1E102KBQ
C1608 JB 1A 224K-T
ECST0JY475R
ECJ0EB1A104K
ECUE1H470JCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECJ0EB1A104K
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1H060CCQ
ECUE1E102KBQ
ECUE1E102KBQ
ECUE1E102KBQ
C1608 CH 1H 470J-T
ECST0JY475R
ECUE1E102KBQ
ECUE1H331KBQ
C1005 JB 1E 223K-T-N
ECUE1E821KBQ
ECUE1E821KBQ
ECJ0EB1A473K
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1H470JCQ
ECJ0EB1A104K
ECUE1H150JCQ
ECUE1H180JCQ
ECJ0EB1A104K
ECJ0EB1A104K
ECUE1H101JCQ
ECJ0EB1A104K
B 5511C
*=Safety critical components
S.=Surface mount
6-7
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
[CHASSIS PARTS]
REF
NO.
ORDER
NO.
MP1
8210017211
8210017350
8310049450
8930052850
8930052970
8210017100
8210017080
8930052981
8010018251
8930052640
8930053170
8930053650
8930052840
8930054540
8930052991
8610010910
8610010920
8510013161
8930053670
8930053000
8510013480
8830001480
8930053210
8830001500
8830001511
8810009220
8930042080
8950004420
8810008970
8810009180
8210017091
8950005310
8510013220
8930053440
8930053431
8810000100
8930053630
8930053680
8810004890
8810005360
8810009560
8810005700
8810009510
8930046000
8930053660
8930053880
8930054010
8930051781
8930053890
MP2
MP4
MP5
MP8
MP9
MP10
MP12
MP13
MP14
MP16
MP17
MP18
MP19
MP20
MP21
MP22
MP23
MP25
MP26
MP29
MP32
MP33
MP34
MP35
MP37
MP40
MP41
MP43
MP44
MP49
MP50
MP51
MP52
MP53
MP54
MP55
MP56
MP57
MP58
MP59
MP60
MP61
MP63
MP64
MP65
[FRONT UNIT]
DESCRIPTION
2337 front panel-1 assembly
[GT]
2337 S-front panel assembly
[GS]
2337 window plate
2337 release button
2337 PTT plate
2337 rear panel
2337 reflector
2337 switch plate-1
2337 chassis-1
2337 key board
[GT]
2337 4-key
[GS]
2336 main seal
2337 T-rubber
2336 top key
2337 terminal-1
Knob N281
Knob N282
2337 main shield-1
2337 side plate
2337 window sheet
2336 PA shield
VR nut (O)
2337 microphone sheet
2337 nut
Nut (I)-1
Screw PH B0 M2 × 8 ZK (BT)
1922 minus terminal
1652 9-pin connector
Screw FH BT No.0 M2 × 3.5 NI-ZU
Screw FH BT No.0 M2 × 5 NI-ZU
2337 terminal holder-1
Antenna connector-103
2337 antenna plate
2337 A-PTT plate
Sponge (GP)-1
Screw PH M2 x 4 ZK
Seal O-ring (AH)
Spring (AG)
Screw PH No.0 M2 × 6 ZK
Screw PH No.0 M2 × 3 ZK
Screw PH BT M2 × 6 ZK
Screw PH No.0 M2 × 4 ZK
Screw PH BT M2 × 4 NI-ZU
1903 microphone sponge
[GS] only
2337 side seal
2337 key sheet
[GT]
2337 4-key sheet
[GS]
Insulation sheet GA-1
2337 T-K sheet
QTY.
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
6
1
1
1
1
1
2
2
1
1
2
8
2
3
8
1
1
1
1
1
1
REF
NO.
ORDER
NO.
DS10
5030001870
LCD EDMMUD1FA0
SP1*
2510001060
Speaker K036NA500-47
MC1
7700002310
Microphone EM-140
1
MP1
MP2
8510013230
8930053320
2337 LOGIC shield
2337 LOGIC spring
1
1
QTY.
DESCRIPTION
1
[MAIN UNIT]
REF
NO.
ORDER
NO.
MP1
MP2
MP3
MP6
MP7
8510013000
8510011180
8410002370
8950005330
8950005320
2336
1923
2337
2337
2337
W5
8950009790
Cable OPC-972
QTY.
DESCRIPTION
VCO case
VCO cover
PA heat sink (using Q1:2SK2974)
9-pin base
contact
1
1
1
1
1
1
Screw abbreviations
B0, BT: Self-tapping PH: Pan head FH: Flat head
NI-ZU: Nickel-Zinc
ZK: Black
[ACCESSORIES]
REF
NO.
EP1
EP2*
MP1
MP2
MP3
ORDER
NO.
QTY.
DESCRIPTION
Optional products Antenna FA-SC55V-1
Optional products Battery BP-210FM
for intrinsically safe version
Battery BP-210 for other version
Optional products 1922 belt clip-1
8210017071
2337 C-panel-1
8810003700
ICOM screw B4
* : Safety critical components
[GT]: IC-F30GT/F31GT
[GS]: IC-F30GS/F31GS
EP1
7-1
EP2
MP1
MP2
MP3
1
1
1
1
1
1
MP40 (C)
W1 (F)
IC-F30GT and IC-F31GT parts
MP2 (F)
MP40 (C)
MP5 (C)
MP20 (C)
MP51 (C)
SP1 (F)
MP19 (C)
MP9 (C)
MP26 (C)
FR
ON
DS10 (F)
MP65 (C)
TU
NIT
MP57 (C)
MP55 (C) MP54 (C)
MP40 (C)
MP17 (C)
MP8 (C)
MP3 (F)
MP10 (C)
MP44 (C)
MP50 (C)
MP53 (C)
MP22 (C)
MP1 (F)
MP58 (C)
MP4 (C)
MP33 (C)
MP59 (C)
MP32 (C)
MP23 (C)
MP37 (C)
MP18 (C)
MP41 (C)
MC1 (F)
MP56 (C)
MP58 (C)
MP43 (C)
MP13 (C)
MP35 (C)
MP2 (C)
MP56 (C)
IC-F30GS and IC-F31GS
MP61 (C)
MP63 (C)
MP64 (C)
CHANNEL SW
MP1 (C)
MP56 (C)
MP1 (C)
MP59 (C)
VR w/ SW
MP3 (M)
MP52 (C)
MP13 (C)
MP56 (C)
MP49 (C)
MP29 (C)
MP56 (C)
MP16 (C)
MP6 (M)
MP25 (C)
MP52 (C)
MP1 (M)
MP2 (M)
MP7 (M)
MP59 (C)
MP63 (C)
MA
IN
U
MP34 (C)
NIT
MP12 (C)
MP60 (C)
MP14 (C)
W5 (M)
Note
7-2
(M): MAIN UNIT
( F ): FRONT UNIT
(C): CHASSIS PARTS
MP59 (C)
MP21 (C)
SECTION 8
SEMI-CONDUCTOR
PARTS LIST
INFORMATION
8 - 1 TRANSISTORS AND FETS
NAME
SYMBOL
INSIDE VIEW
NAME
SYMBOL
C
2SA1362 GR
G2
AEG
B
INSIDE VIEW
3SK206-T1 U78
U78
3SK293
UF
CPH3403-TL
C
E
DTA144EUA
B
DTC144EUA
SYMBOL
C2
A
T3
BO
C
A
C
N
E
A1
A1
06
S
DAP202U
P
E
B
A2
C1
C2
C
UN911H
K1
6P
D
MA111
1B
MA2S111
A
A
C
E
B
C2
C1
(TOP VIEW)
2SK2974
K2974
C1
M1U
INSIDE VIEW
C
DTC144TE TL
S
NAME
DAN202U
B
D
K1
G
MIN
B2
E
26
S
2SK2973
E2
MA742
C
XY
G
MA713
E1
1SV245
HVC350BTRF
D
2SK1829
S
16
E
S
5N
A1
C
C
G
2SK880-Y
INSIDE VIEW
C2
8 - 2 DIODES
G
BR
LG
AB
QO
R25
B
SYMBOL
A2
S
KC
C
2SC4081 R
2SC4116 GR
2SC4213 B
2SC4215 O
2SC4226 R25
B1
NAME
D
BARB
B
INSIDE VIEW
C1
XP6501 AB
C
2SB1132 R
SYMBOL
G1
D
E
NAME
D
D
S
S
G
G
XP1214
MA77
9H
B1
E1
4B
A
C
B2
8-1
MA8024
2.4
MA8030-H
3^0
MA8056-M
5-6
MA8062-M
6-2
A
C
SECTION 9
BOARD LAYOUTS
9 - 1 FRONT UNIT
• TOP VIEW
The combination of this page and the next page shows
the unit layout in the same configuration as the actual
P.C. Board.
MICROPHONE
✽
7
4
1
P0
P1
0
8
5
2
P2
#
9
6
3
P3
Surface
9-1
Inside 1
Inside 2
Under side
FRONT UNIT
The combination of this page and the previous page
shows the unit layout in the same configuration as the
actual P.C. Board.
• BOTTOM VIEW
F3
PTT
1
5
10
15
LCD
20
25
30
35
40
F3
NC
NC
VR2
VR1
VOUT
VEE3
VEE2
CAP+
CAP–
VEE
VDD
PMODE
VSS
OSC1
OSC0
D7
D6
D5
D4
D3
D2
D1
D0
RDB
WRB
SCL
P/S
M86
M/S
RS
CSB
RESB
VS/TE
V4
V3
V2
V1
V0
NC
NC
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
F0
F2
SPEAKER
Surface
Inside 1
to MAIN unit J3
9-2
Inside 2
Under side
9 - 2 MAIN UNIT
• TOP VIEW
OPC-966
EM-80
EM-89
AD-52
HS-93
7
8
5
6
3
4
1
2
INT SP SW
AF VR
POWER SW
to FRONT unit J1
BATTERY
BDET
1
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
9
AFO
VCC
DETECT
MICE
RESET
XRXD
XTXD
MIC
PTT
UNIVERSAL
CONNECTOR
MP6
The combination of this page and the next page shows
the unit layout in the same configuration as the actual
P.C. Board.
26
R193
15
16
1
30
15
16
1
30
9 8 7 6 5 4 3 2 1
CH
SELECT
S1
1
2
3
6
5
4
BATTERY+
ANT
Surface
9-3
Inside-1
Inside-2
Under side
MAIN UNIT
The combination of this page and the previous page
shows the unit layout in the same configuration as the
actual P.C. Board.
• BOTTOM VIEW
3
4
5
6
7
8
9
PTT
MIC
XTXD
XRXD
RESET
MICE
DETECT
VCC
AFO
1
2
INT SP SW
AF VR
POWER SW
R193
1 2
3 4 5 6
7 8 9
6
3
4
5
CP3
Surface
Inside-1
Inside-2
9-4
Under side
1
2
CH
SELECT
S1
SECTION 10
BLOCK DIAGRAM
Q13
XP6501
IC2
TC75S51F
X1
CR-667
136-174 MHz
IC1
SA7025
DRIVE
AMP
D7
1T365
LOOP
FILTER
15.6 MHz
TCXO
FRACTIONAL N
BUFF
MOD
Q12: 2SC4226
D8, D43–D45: HVC350B
×2
D4, D5: MA77
TX/RX
SW
BUFF
Q3
2SC4226
Q2
2SK2973
Q1
2SK2974
YGR
AMP
PRE
DRIVE
PWR
AMP
D2
MA713
Q22
DTA144EU
ATT
Q17 2SC4116
X2
Q16 DTA144EU
CDBCA450CX24
W/N
W/N
SW
IC3
TA31136FN (D)
IF
RSSI
SECOND MIXER
IF AMP
SQL AMP
DETECTOR
FI1
FL-322
XTAL
BPF
AMP
Q19
3SK206
31.65 MHz
D18
HVC375B
D19
HVC375B
BPF
BPF
T4
GATE
CTRL
D20
HVC375B
D21
HVC375B
BPF
BPF
T2
T1
RF
AMP
MIXER
RSSI
TMUT
MUTE
SW
APC
AMP
Q21
2SK1829
Q18
2SC4215
NOIS
LPF
IC4
TC75S51F
BUFF
BPF
ANT
SW
Q7
2SC4215
LPF
31.2 MHz
D1, D24, D25
MA77
PWR
DET
TX VCO
Q15
2SC4116
DSIN
Q6
2SC4215
Q8
2SC4215
RX VCO
PLL IC
MOD
MAIN UNIT
VCOS
Q11: 2SC4226
D6, D40–D42: HVC350B
BUFF
LVIN
DTC144EU
XP1214
VCO
SW
RIPPLE
FILTER
S5V
Q14
2SK880
Q9
Q10
UNIVERSAL
CONNECTOR
Q20
3SK293
T4
J4
CONNECTOR
T3
W/N
VCC
W/N
SW
DSIN
SQIN
FI2
SFPC450E
D15
DAN202U
D16
DAN202U
CERAMIC
BPF
W/N
SW
FI3
SFPC450G
Q27
2SC4212
Q26
DTC144EU
FSW
FIL
SW
W/N
SW
CERAMIC
BPF
XTXD, XRXD, RES
PTT
W/N
MIC
MICI
Q23 2SB1132 R
Q24 XP6501
IC7C
NJM2902V
VCC
LPF
AFON
AFMT
AF AMP
REG
IC19
BU4053BCFV
IN/EXT
MIC SW
IC13
DA3
AFOUT
IC19
BU4053BCFV
PTT/MD1
SW
COMPANDER
IC9 TC35453F
MIC+
DETECT
IC10
NJM2902V
AMP
HPF
HPF
LPF
IC13
DA1
IC13
M62364FP
FRCN
MSK
MOD
PTOT
IC18 TA75S01F
COMPRESSOR
LIMIT
AMP
AMP
BUFF
D/A
BEP1
TONE
SCL
SDA
MCIN
TRD
MSKE
DIN
SCK
APST
12.288 MHz
X3
CR-681
IC2
TC75S51F
SP
SW
MC1
EM-140
MIC
AMP
MIC
INT MIC
BEP2
BEEP
IC13
DA2
MCOT
D27
MA77
PTT
SHIFT
SW
VOX
Q47
2SC4081
IC27
M62334
SO
SCK
DAST
AMP
B
AMP
DTPD
DTSD
DTAC
DDST
PTIN
G
SIG1, SIG2,
CTCS, TONE
INT SP
SP–
Q6, Q7
CPH3403
Q8
2SC4081
Q9
DTC144EU
IC7B
NJM2902V
IC17
LC73872M
OSCI
SPCN
IC5
TA7368F
LPF
HPF
LPF
T1
T2
T3
T4
D/A
DTMF
DECODE
MSK
DEMOD
BPF
HPF
SPLO
MOD
SP+
AF
AMP
AMP
EXPANDER
AMP
CSFT
A
VOXT
REGS1
REGS2
RTM
RDT
FCLR
RDB WRB RESB
D0-D7
LCD MODULE
RS
J1
BEP1
D
SIG1
POWER SW
F
1
MCIN
MCOT
AFON
PTIN
PTOT
J2
BEP2
C
SIG2
OPTION
UNIT
X4
CR-563
3.58 MHz
REM
OPTION
UNIT
E
CIRQ
SI
SO
RMUT
MMUT
OPV11
OPV12
OPV13
OPV21
OPV22
OPV23
CCS
SCK
OPT11
OPT12
OPT13
BATT
FUSE
IC7D
NJM2902V
Q32 2SB1132
Q33 XP6501
Q40
XP1214
IC13
DA4
FIL
SW
Q41
DTC144EU
FIL
SW
MCIN
MCOT
CTDA
+5V
DUSE
IC30
TC7S66FU
Q44
DTC144EU
CTCSS
DTCS
SW
RES
KS0-3
D0-D7
EXPAND
KEY
MATRIX
FRST
IC12
AN8005M
+5
CPU
CPU5V
KR0-3
RESTORATION
IC20B
NJM2904V
IC20A
NJM2904V
CONTROL LINE
T5C R5C
R5V
COMMON LINE
R5
REG
TX LINE
RX LINE
Q31 2SA1362
S5
REG
RXDT
IC31
TC75S51F
DATA
LPF
VCC
Q1, Q2
2SC4116BL
Q30 2SA1362
S5V
DATA
LPF
F0
F1
F2
F3
IC14
HD64F2238
Explanatory notes
PTIN
PTOT
10 - 1
+5
REG
IC1
TC74VHC373FT
CPU
IC15
S-80942ANMP
RESET
LPF
CTCS
OPT21
OPT22
OPT23
2
F1
VCC
IC23
BU4094BCFV
BUSY
DTPD
DUSE
W/N
FSW
S5C
AFMT
SPCN
T5V
T5
REG
Q3 DTC144TE
MSCK
MSO
EXPANDER
Q29 2SA1362
SDEC
RESB
SO
SCK
EXST
EEPROM
IC24
HN58X2464TI
MAIN UNIT
EEPROM
IC16
HN58X2464TI
CB10
CB11
CB12
CB13
CH
SELECT
S1
EC10SP16-47
DS1-4
DS6-9
DS11-12
DS14-15
LN1371G-(TR)
KEY
LED
SW
BUSY
LED SW
VCC
BUSY LED
DS13
LMJ310M6RA
Q4 DTC144TE
TX
LED SW
VCC
TX LED
DS5
LN210C6ARA
FRONT UNIT
C21
1
C7
1
R7
560k
C9
1
C1
0.1
C4
1
f =41 kHz
5V
C3
0.1
R4
820k
C23
1
C22
0.1
0V
Q4
DTC144TE
R1
3.3k
R2
1.5k
R3
22
C20
47p
C8
1
C10
1
SIG2
OPT21
OPT22
OPT23
Q1
2SC4116
R5
820k
D4
C26 MA111
0.1
R18
100k
C19
0.1
R6
390k
C6
1
Q3
DTC144TE
J1
RX: 0V
TX: 5.0V
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
F3
S3
F2
S2
F1
F0
D1
MA111
S110
DS6
DS11
LN1371G- LN1371G[GT] only [GT] only
S103
S102
KS4
11
12
13
14
15
16
17
18
19
20
S4
R58 1k
F
R307
100k
MSKE
R65
OPV22 47k
RGS2
R66
OPV21 47k
IC1
TC74VHC373FT
S101
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
OUT
VCON
2
C95
47p
C96
47p
C99 47p
C97
47p
1
2
3
4
5
6
7
8
9
10
C98
0.01
L27
1.8 H
C87
3p
CLOCK
DATA
STROBE
VSS
RFIN
RFIN
VCCP
REFIN
RA
AUXIN
SCK
SO
CIRQ
R347
4.7
3
R77
15k
R73
100k
R78
22k
R79
12k
+5V
R80
22k
C110
0.1
RMUT
R75
100k
R86
82k
R88
47k
D14
DAP202U
Q16
DTA144EUA
RX: 4.6V
TX: 0.1V
C114
0.1
R85
330
C267
0.01
MMUT
C112
220p
C423
0.1
R87
3.9k
S112
S109
S108
C13
47p
S107
LED OFF: 0V
LED ON : 5.0V
DS9
LN1371G[GT] only
D2
MA111
KS2
DS15
LN1371G[GS] only
Q5
DTC
144TE
RDB
WRB
RS
C229
47p
C228
470p
RX: 5.0V
TX: 0V
DSIN
R187
G
PTIN
C310
47p
C231
0.0047
D0
R289
100k
+5V
R323
100k
R11
3.3k
Q45
UN911H
VCC
VCC
SPCN
C225
0.047
C234
47p
S1
EC10SP16-47
1 3
1 C1 2 4
2
5
C2 4 6
8
R186
68k
R185
120k
R288
10k
R188
100k
S12
S11
S10
C366
47p
C367
47p
C421
0.1
C203
0.0022
R298
100k
R376
R192 1k
100k
R330
4.7
Y1
Y0
Z1
Z
Z0
INH
VEE
VSS
VDD
Y
X
X1
X0
A
B
C
C235
22
C414
0.1
C354
0.001
Q30
2SA1362
RX: 5.0V
TX: 0.8V
C356
47p
R199
4.7k
R197
4.7k
DC SW
R200
10k
C239
0.01
C236 C237 C238
22
22
22
RX: 0.8V
TX: 5.0V
UNIVERSAL
CONNECTOR
CP1
C241
0.01
CP2
KR0
KR1
KR2
KR3
PTT
S1
PTT
XTXD
MIC
PTT
INT MIC
MC1
EM-140
R12
33k
C25
47p
C16
0.001
Q6
CPH3403
Q8
2SC4081
R22
470k
INT SP : 0V
EXT SP: 4.8V
R21
100k
R20
470k
Q9
DTC144EUA
FRONT UNIT
11 - 1
C28
0.01
Q7
CPH3403
R24
47k
RX: 0V
TX : 2.7V
C24
0.01
R25
180k
C413
0.1
R277 1k
C30
0.1
R27
12k
R366
82k
5
R284
1k
2
R362
5.6k
TX SIGNAL
D36
MA8056 M
REG
7.5
IC12
AN8005M
R202
1k
3
C242
4.7
C448
0.0012
C24
0.0
IC17
LC73872M
C450
0.1
1
2
3
4
5
6
7
C254
4.7
C384 C385
0.001 0.1
C386
47p
VDD
NC
EST
STD
ACK
SD
LOADB
INPUT
NC
PD
OSCO
OSCI
NC
VSS
14
13
12
11
10
9
8
DTMF DECODE
R368
390k
C449
0.1
I
G
C244
0.001
C243
47
0.9V
C257
0.1
R157
22k
R312
22k
R313
33k
R314
33k
R315
33k
C394
0.018
C395
68p
Q43
2SC4116
C443
0.001
R316
2.7k
R218
39k
C396
1
S5V
R5V
DSIN
+5V
R206 100
R210 390k
C248
MICO 0.018
SPCN
HV
[GT]: IC-F30GT/F31GT
[GS]: IC-F30GS/F31GS
5.0V
O
R367
1.5k
5
4
C393
1
D35
MA8056 M
C195
470p
Q32
2SB1132
L45
1.8 H
2
R369
180k
C452
0.1
D34
MA8056 M
1
4
R201
2.2k
3
MD2
D30
MA8062 M
IC31
TC75S51F
C447
820p
RES
XRXD
XTXD
RX: 0V
TX : 2.2V
Note
R364
100k
C353
0.001
1
3
2
R26
15k
C355
0.001
R280 1k
C428
0.1
C29
0.001
R325
10k
R365
39k
C445
0.022
R276
47
AFOUT
R279 1k
C429
47p
IC2
TA75S01F 5
4
C27
270p
R278
1k
C451
47p
W3
6
1
C240
0.01
RX SIGNAL
R363
100k
SPCN
R285 10k
PTT
SP+
MIC+
R23 10k
INT SP: 0V
EXT SP: 4.3V
MP6
9
8
7
6
5
4
3
2
1
Q33
XP6501
S5V
R375
4.7k
AFO
VCC
DETECT
MICE
RESET
XRXD
C15
47p
C17
47p
R203
10k
R198
10k
R196
10k
R195
4.7k
+5V
16
15
14
13
12
11
10
9
C434
0.1
C433
47p
RX: 5.0V
TX: 0V
Q31
2SA1362
Q29
2SA1362
HV
1
2
3
4
5
6
7
8
C20
4.
C456
0.1
R372
33k
R373
4.7k
C213
4.7
C214
0.1
R180
15k
VCC
VCC
IC19
BU4053BCFV
R371
22k
5.0V
T5V
F1
KAB
2402322NA29
R166
10k
C215
0.1
C455
0.1
C224
R370 0.1
47k
5.0V
AFVI
D31
MA2S111
C219 120p
R173
150k
C232
0.0022
RX: 0V
TX: 5.0V
D46
MA742
S5V
+5V
R5V
AF VR R193
10k
R175
5.6k
C218
0.0047
Q47
2SC4116
C446 820p
SP1
1
VCC
D38
MA2S111
INT SP
C
0.
MICI
C432
0.1
R190
100k
Q46
DTC144EUA
C401
47p
INT SP SW
KS0
C116
470p
C118
0.001
VAG
R217
470
D3
MA6S121
R94
3.3k
11
B
MCOT
MCIN
SENC
S16
C1
10
C117
0.001
VAG
L47
1.0 H
PTIN
CB10
CB11
CB12
CB13
POWER
C14
47p
4
3
C233
0.1
KS1
R9
3.
C217
AF FIL
R184
12k
AFOUT
R10
1.5k
R9
220
C124
C125
10
100p
16
15
14
C420 0.001
13
12
11
10
9
IC7A 0.1
NJM2902V
2
C230
10
+5V
C192
0.0047
R183
1.5k
C398 0.0047
C226
0.047
C227
0.033
4.7k
Q27
2SC4213
R189
470
PTOT
R317
C399 470k
0.0047
C397
0.0047
R172
68k
C216
0.047
R168
39k
A
RESB
VCC
KR0
KR1
KR2
KR3
FRST
C365
47p
Q2
2SC4116
R91
10k
R90
47
MIXIN
GND
N-REC
N-DET
RSSI
IFOUT
QUAD
AFOUT
R93
47k
SDEC
C12
47p
3 MULTI
Q17
2SC4116
R92
47k
C422
0.1
S5C
DS8
LN1371G[GT] only
C77
0.1 [F30G]
0.22[F31G]
C79
0.1 [F30G]
0.001[F31G]
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
C115
0.001
C111
220p
R5C
S104
C81
47p
C76
100p
S5V
T5C
S105
R47
10k[F30G]
20K[F31G]
IF
IC3 TA31136FN
1
2
3
4
5
6
7
8
C113
0.01
R82
15k
FSW
S106
C80
0.1
R61
220k
R89
1.5k
D16
DAN202U
3
R81
FI3 SFPCA450KG1A 4.7
2
1
DSIN
S111
R45
10
C78
0.001
Q15
2SC4116
FI2 SFPCA450KE4A
2
1
D15
DAN202U
CCS
CH SELECT
KS3
KS2
KS1
KS0
KR0
KR1
KR2
KR3
MIC+
SPCN
SP+
PTT
KS3
C84
12p
R4
82
1.5
R44
6.8k[F30G]
4.7k[F31G]
C82
10p
C85
2.5p
C86
5p
20
19
18
17
16
15
14
13
12
11
VDD
TEST
LOCK
RF
RN
VDDA
PHP
PHI
VSSA
PHA
L26
1.8 H
R14
100k
DS12
DS7
LN1371G- LN1371G[GT] only [GT] only
IC1
SA7025
DK-T
R62 C83
1.2k 0.01
L28
1.8 H
C439
0.001
W/N FILTER
E
D7
D6
D5
D4
D3
D2
D1
R46
4.7k[F30G]
12k[F31G]
L25
1.8 H
S5V
R5V
C
MCOT
MCIN
DS14
LN1371G[GS] only
FLAC N PLL
VCOS
10
9
8
7
6
5
4
3
2
1
C18
47p
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
VCC
R57
2k
C108 R59 C91
47p 2k 47p
BEP2
D13
DAP202U
R49
6.8k
W4
R67
100k
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
C101
0.001
R51
10k
C109
0.1
SCK
SO
PLST
ULCK
J3
W5
RESB
VCC
S5
OPV23
1
SI
C2
0.1
D7
D6
D5
D4
D3
D2
D1
D0
RDB
WRB
RS
R17
100k
R64
47k
FCLR
R53
220k
C103
10p
C430
0.001
RSSI
10.3V
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
PTOT
4
2
REM
DS1
LNJ310M6URA
5
C102
0.0047
Q14
2SK880Y
PLRS
D
To optional unit
OPT2 J2
SQL CLOSE: 0V
SQL OPEN : 5.0V
3
CP7
R48
10k
C100
0.001
R50
1k
LV
X1
CR-667
15.600 MHz
LVIN
AFON
DS5
LNJ210C6ARA
J2
5.0V
C11
1
DS13
LNJ310M6URA
1
C107
47p
IC2
TC75S51F
SQIN
DS4
LNJ310M6URA
DS2
LNJ310M6URA
R8
560
R55 22k
FRCN
3
MICO
13.1V
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
DS3
LNJ310M6URA
R13
330
SPLO
R52 100
4
C104
0.1
DTPD
NC
NC
V0
V1
V2
V3
V4
VS/TE
RESB
CSB
RS
M/S
M86
P/S
SCL
WRB
RDB
D0
D1
D2
D3
D4
D5
D6
D7
OSC0
OSC1
VSS
PMODE
VDD
VEE
CAP–
CAP+
VEE2
VEE3
VOUT
VR1
VR2
NC
NC
LCD
+5V
BEP1
D10
DAN202U
C105
0.001
R54
100
NOIS
DS10 EDMMUD1FA0
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
R341
27k
C106
0.1
R296
47k
To optional unit
OPT1 J1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
C427
4.7
PLLIN
VOLTAGE DIAGRAM
OPV11
OPV12
OPV13
R295 47k
REF
W/N
SECTION 11
R294 47k
15.6 MHz 970 mVp-p
VCC
T5V
S5V
+5V
GND
BUSY
AUX
SIG1
OPT11
OPT12
OPT13
APST
DIN
RGS1
R60
100k
BATTERY
GND
BDET
HV
CP3
CP4
CP5
C359
0.001
except[IS]
C358
470p
except[IS]
L53
1 H
C357
47
except[IS]
C318
0.01
R208
15k
BDET
VOXT
C249
0.018
R209
330k
R207
22k
C252
470p
C251
2.2
R275
22k
R274
22k
VOX
1
C250
470p
5
4
3
R211
1.2k
2
D29
MA2S111
IC18
TA75S01F
R212
1.8M
C352
0.039
RX SIGNAL IC20B
NJM2904V
5
R273
22k
6
7
C351
0.1
C350
0.01
C349
0.0068
DUSE
C253
0.001
MAIN UNIT
Q41
DTC144EUA
R.FIL
R356
180k
R355
47k
C67
12p
C373
10p
D7
1SV245
R41
220k RX: 2.3V
TX: 2.4V
R42
100k
3 MULTI
15
SC4116
C68
18p
C69
22p
C376
0.001
RX: 2.6V
TX: 2.5V
C64
0.001
R24
220
Q10
XP1214
C66
0.5p
L46
3.3 H
4
TX VCO
RX: 0V
TX: 4.9V
Q8 2SC4215
R29
10k
R63
56
C53
47p
Q18
2SC4215
C130
0.001
Q19
3SK206
FI1
FL-322
31.650 MHz
6 5 4 3
T4
AUDIO
PROCESSOR
C457
100p
VAG
C215
0.1
C455
0.1
C224
R370 0.1
47k
R371
22k
16
C213
4.7
C214
0.1
R180
15k
11
10
9
8
7
6
5
4
3
2
1
CST
AGND
TXFO
IDCIN
IDCGS
TXOUT
MSKIN
MSKGS
RXIN
RXGS
RXFO
IC9
TC35453F
C454
18p
C208
4.7
R152
150k
R227
100k
C147
0.001
R327
47
C437
6p
L51
56nH
R126
100k
R115
10k
L40
47nH
L39
47nH
D23
MA2S111
L38
56nH
C165
4p
C161
0.001
D24
MA77
C263
0.1
R162
68k
R161
68k
9 C202
270p
C200
56p
R163
33k
7
C444
330p
R155
39k
C362
0.0012
R176
56k
R177
18k
C162 R125
0.001 10k
Q26
DTC144EUA
5
4
6
C187
47p
R153
4.7
D47
MA8024
R179
27k
C172
4.7
C171
0.01
1
C186
0.1
2
C185
0.1
R133
2.2k
C173
0.01
C174
0.001
R69
100k
10
NC
POUT
9
VCC
PWGND
NC
PREGND 8
VIN
PHASE 7
NF 6
RIPPLE
L41
EXCCL3225U1
R135
10
3
R139
1k
R132
180k
C440
0.001
IC5 TA7368F
1
2
3
4
5
Q24
XP6501
R137
2.7k
R140
1M
C189
0.001
1
5
R131
330k
Q23 2SB1132
AF REG
RX: 0V
TX: 5.0V
R130
10k
3
4
C442
4.7
AF ON : 7.5V
AF OFF: 0V
Q22
DTA144EUA
R129
3.9k
IC4
TC75S51F
2
D39
MA8030H
D25
MA77
D26
MA2S111
5
R178
27k
C177
470p
R128 100k
APC
R328
1k
C170
9p
C168
8p
IC7B
NJM2902M
10
8
C176
0.001
D2
MA713
C167
6p
C184
10
R138
3.3k
C183
0.001
R136
6.8k C182
0.018
R134
10
C181
10
R321
2.2k
C178
100
C179
0.047
C180
47p
R222
100k
C188
47p
AF AMP
C425
0.001
C375
0.1
13
R218
39k
C426
0.22
S5V
R5V
RX SIGNAL IC20B
R273
NJM2904V
22k
5
R269
120k
R270
18k
C348
0.1
C341
0.015
R271
220k
R266
47k
R258
22k
C346
0.0033
DUSE
Q41
DTC144EUA
C347
0.1
R272
68k
C415
2.2
R267
47k
R248
1k
C338
47p
C337
47p
C335
47p
C325
47p
C294
47P
CTDA
R374
47k
Q40
XP1214
4
RDT
CB10
CB11
CB12
CB13
1
BUSY
DTPD
2
W/N
3
IC20A
NJM2904V
R331
470k
IC30 TC7S66FU
1
2
3
5
C319
47p
R245
1k
4
Q44
DTC144EUA
C306
0.1
R251
1k
P30/TXD0
PE5/D5
PE6/D6
PE7/D7
PD0/D8
PD1/D9
PD2/D10
PD3/D11
PD4/D12
PD5/D13
PD6/D14
PD7/D15
CVCC
PC0/A0
VSS
PC1/A1
PC2/A2
PC3/A3
PC4/A4
PC5/A5
PC6/A6
PC7/A7
PB0/A8/TIOCA3
PB1/A9/TIOCB3
PB2/A10/TIOCC3
PB3/A11/TIOCD3
CIRQ
91
P76/RXD3
P77/TXD3
P36
P35/SCK1/SCL0
P34/RXD1/SDA0
P33/TXD1/SCL1
P33/SCK0/SDA1
P31/RXD0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
R240
1k
C298
47p
R293
100k
C307
47p
C308
47p
C303
47p
C302
47p
C301
47p
IC14 HD64F2238FA13
C313
47p
PF0/BREQ/IRQ2
PF1/BACK/BUZZ
PF2/WAIT
PF3/LWR/ADTRG
PF4/HWR
PF5/RD
PF6/AS
PF7
MD2
FWE
EXTAL
VSS
XTAL
VCC
STBY
NMI
RES
OSC1
OSC2
MD1
MD0
AVCC
VREF
P40/AN0
P41/AN1
C380
47p
C381
47p
R297
1k
C382
47p
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
QS
QS.
IC23
BU4094BCFV
.STR
D
CLK
OE
1
2
3
15
C378
0.1
8
EXST
SO
SCK
RESB
C276
22p
R224
100k
C299
47p
C300
47p
C331
47p
C332
47p
C333
47p
C340
47p
C339
47p
C334
47p
R250
1k
C277
7p
C278
0.01
R232
12k
C279
0.01
NOIS
DTSD
R246 1k
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
T5C
R5C
TMUT
DDST
C309
47p
C311
47p
C312
47p
C404
47p
C405
47p
W3
D33
MA2S111
RES
CPU5V
AN0
AN1
C317
0.0047
C316
0.0047
R233
100k
Q39
2SC4116
MD2
R234
10k
XTXD
SCK
SO
DAST
C280 D27
33p MA77
X3
CR-681
12.288MHz
C275
47p
PLST
PLRS
16
4
5
6
7
14
13
12
11
9
10
R235
1k
CSFT
DEST
C315 C314
47p 47p
C379
47p
C289
47p
R231
12k
W2
R253
100k
R252
1k
VCOS
FSW
AFMT
SPCN
S5C
R332
100k
95
96
C297
47p
R223
220k
R244 1k
C377
47p
DUSE
MSCK
93
C288
47p
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
RXDT
R264
470
C364
47p
XOUT
C287
47p
12.29 MHz
3.4 Vp-p
RGS2
MSKE
FCLR
1
8
C286
47p
R329
10k
C293
47p
XIN
C292
47p
100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
C320
47p
C336
47p
R239
1k
R247
1k
KR2
KR3
R322
220k
DIN
RGS1
4
3
C295
47p
APST
R220 100k
8
7
6
5
R254
180k
R268
100
2
R219 10k
REM
C342
0.1
C345
0.01
C349
0.0068
VCC
WP
SCL
SDA
A0
A1
A2
VSS
C326 C324
47p 47p
CPU5V
EXST
C268
0.1
C327
47p
C328
47p
C291
47p
R238
1k
PG1/CS3/IRQ7
PG0/IRQ6
P70/TMRI01
P71/TMRI23
P72/TMO0/CS6
P73/TMO1/CS7
P74/TMO2/MRES
P75/TMO3/SCK3
DAST
SCK
SO
C343
820p
IC7D
NJM2902V
8
7
6
5
5
7
C351
0.1
VCC
WP
SCL
SDA
C383 0.1
C412
47p
C273
47p
C458
0.1
C304
47p
R291
100k
IC15
S-80942CNMC-G9C
R299
1k
SENC
CTDA
SDEC
RXDT
AFVI
VOXT
LVIN
RSSI
12
14
R262
5.6k
CTCS
R257
22k
R259
47k
R260
47k
R261
47k
PTOT
RMUT
MMUT
KR0
KR1
C296
47p
R151
150k
IC24
HN58X2464TI
S5V
C396
1
C350
0.01
1
2
3
4
C407
0.1
IC27
M62334FP
R281 R182 R181
27k 27k 27k
FRCN
EEPROM
8
7
6
5
C371
47p
R242
1M
P13/TIOCD0/TCLK
P14/TIOCA1/IRQ0
P15/TIOCB1/TCLK
P16/TIOCA2/IRQ1
P17/TIOCB2/TCLK
AVSS
P97/DA1
P96/DA0
P47/AN7
P46/AN6
P45/AN5
P44/AN4
P43/AN3
P42/AN2
R225
100k
C259
0.01
A0
A1
A2
VSS
C305
47p
D5
D6
D7
RESB
R150
220k
IC16 HN58X2464TI
1
2
3
4
C329
47p
C265 C266 C402
470p 47
47
C323 C322 C321
47p
47p 47p
IC13
M62364FP
SCL
SDA
T4
T3
T2
T1
TONE
1
2
3
4
C264
47
R243
1M
R230
12k
MMOD
RTM
DTAC
TRD
ADSL
C257
0.1
C443
0.001
6
D/A
C410
0.1
R157
22k
Q43
2SC4116
R316
2.7k
C258
0.1
R324
470
14
13
12
11
10
9
8
DTMF DECODE
C424
470p
L43
4.7 H
MSO OPT12 OPT11 OPT13 OPT23 OPT21 OPT22 SDA
R237 1k
R236 1k
D1
D2
D3
D4
P10/TIOCA0/A20
P11/TIOCB0/A21
P12/TIOCC0/TCLK
VDD
NC
EST
STD
ACK
SD
LOADB
C411
4.7
BEP2
IC17
LC73872M
INPUT
NC
PD
OSCO
OSCI
NC
VSS
C247
10
C246
0.001
VIN8
VOUT8
VOUT7
VIN7
GND
RESET
VDAREF
DO
VIN6
VOUT6
VOUT5
VIN5
C283 47p
C284 47p
C285 47p
AUX
PG3/CS1
PG2/CS2
R221 33k
VIN1
VOUT1
VOUT2
VIN2
VDD
LD
CLK
DI
VIN3
VOUT3
VOUT4
VIN4
91
93
95
96
RDB WRB RS
XRXD
SI
86
p
1
2
3
4
5
6
7
8
9
10
11
12
C262
470p
BEEP
C282 47p
PA0/A16
PA1/A17/TXD2
PA2/A18/RXD2
PA3/A19/SCK2
85
R354
3.9k
FRST
CCS
SCL
D0
R226
NTCG20 4M 473JT
CPU5V
R345
1k
24
23
22
21
20
19
18
17
16
15
14
13
R249
1k
PB5/A13/TIOCB4
PB6/A14/TIOCA5
PB7/A15/TIOCB5
C254
4.7
D/A
I
G
C244
0.001
C243
47
1
2
3
4
5
6
7
R216
100k
[GT] only
7.5V
BEP1
C450
0.1
H
UNIT
RX: 2.6V
TX: 0V
IC7C
NJM2902M
C9
22p
R127
100
D21
HVC350
ULCK
DSIN
C260
0.001
IC12
AN8005M
DDST
DTAC
DTSD
DTPD
C242
4.7
5
2
9
16
15
14
13
12
11
10
9
R3
2.2k
R5 4.7k
RX BPF
PE4/D4
PE3/D3
PE2/D2
PE1/D1
PE0/D0
PG4/CS0
SPLO
R344
1k
REG
R202
1k
3
R215
1M [GT]
100k [GS]
BEEP
4
R201
2.2k
R274
22k
C146
0.001
R116
100k
R117
270
BDET
MOD
C408
0.1
C409
0.1
RTM
RDT
FCLR
MSKE
TRD
DIN
SCK
RGS1
RGS2
APST
3.58 MHz
2.8 Vp-p
5.0V
Q32
2SB1132
O
5
VDD
Y
X
X1
X0
A
B
C
C441 R4
47p 2.2k
C14
56p
Q1
2SK2974
C20
0.001
R8
18k
C12
22p
VAG
SQIN
R343
1k 2
C453
15p
C195
470p
MICO
R203
10k
2
R7
22
6
R349
1k
C281 R229
0.1 100k
R292
5.6k
VCC
CPU5V
+5V
1
Y1
Y0
Z1
Z
Z0
INH
VEE
VSS
IC29
BU4053BCFV
D1
MA77
AFOUT
C434
0.1
1
A1362
5
C400
0.001
1
2
3
4
5
6
7
8
C199 R159
120p 100k
VCC
5
C160
7p
R1
82k
C416
10p
CPU5V
C433
47p
6
D22
MA2S111
D20
HVC350
L37
56nH
VAG
5.0V
33
P6501
R336
100k
R318
33k
C261
0.1
C30
0.1
L8
15nH
R141 68k
C205
0.1
C197
0.01
X4 CR-563
3.579545 MHz
RX: 5.0V
TX: 0V
44
43
42
41
40
39
38
37
36
35
34
EXPIN
EXPGS
ECHG
EXPO
PWRIN
PWRGS
PWRON
PWROP
MSKST
VSSA
VSSD
R124
Q21 470k
2SK1829
VCC
R228
100k
C406
0.022
C198
0.0047
C121
0.1
C456
0.1
R372
33k
R373
4.7k
C207
0.1
MICIN
MICGS
CALO
ALCO
CMPIN
CCHG
CMPO
TXFI
VDDA
VDDD
STB
DIN
DCK
REGS1
REGS2
XOUT
XIN
MSKE
TRD
RTM
RDT
FCLR
R173
150k
R166
10k
12
13
14
15
16
17
18
19
20
21
22
C219 120p
R165
47k
23
24
25
26
27
28
29
30
31
32
33
1
C206 0.1
C193
2.2
C159
0.001 R122
1.8k
+5V
R164 220k
R175
5.6k
C218
0.0047
C155
0.001
C154
47p
C8
0.001
L5
50nH
C175
0.1
C163
1p
C156
5p
C1
33p
R121
4.7
VCC
C217
IC7A 0.1
NJM2902V
C142
0.001
C139
0.001
AN0
R167 470k
R113
220k
R114 10k
R111
150k
C158
47p
R119
390k
R334
4.7k
C141 C143
0.001 7p
R112 10k
R171 68k
R174
27k
R352 10k
D19
HVC350
C138
0.001
C403
0.001
L7
7.5nH
R123
47k
R118
100k
C2
33p
L4
4.7 H
L10
25nH
R6 4.7k
R120
15k
Q20
3SK293
C145
0.001
D18
HVC350
C137
6p
RX: 0.9V
TX: 0V
MOD
L36
56nH
C3
18p
C29
0.001
C157 0.47
RX: 3.9V
TX: 0V
C140
1.5p
C135
5p
L52
L33
0.1 H 56nH
C151
0.001
RX BPF
R360
470
R359
470
R105
C134 4.7k
0.001
R103
220
C128
7p
C22
0.001
C31
0.1
RF AMP
RF AMP
C150
47p
C149
470p
C148 R110
0.001 4.7k
C438
0.001
C18
0.001
RX: 0V
TX: 2.8V
W/N
C122
47p
R102
270
1
C133
0.001
R109
100
AN1
L42
1.8 H
2
R358
12
MAPD
R95
4.7
C119
0.001
C132
0.01
L31
0.82 H
C131
27p
MCF
R99
1k
C369
8p
MMOD
C116
470p
MIXER
R340
180k
R98
100k
C120
0.001
C118
0.001
C360
1
ADSL
R93
47k
R94
3.3k
C127
2.2
MSCK
MSO
R92
47k
C123
100p
C117
0.001
Q17
2SC4116
C115
0.001
C126
470p
Q2
2SK2973
R10
68
R12
10k
C38
0.001
C6
0.001
FINAL
C19
150p
TO ANTENNA
MP3
S5V
L44
1 H
L13
18nH
Q3
2SC4226
D5
MA77
L35 1 H
RSSI
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
R361
470
R96
3.9k
C27
0.001
CP1
C417
10p
CP2
C7
47p
C21
470p
C418
5p
L9
EXCCL3225U1
PRI AMP
C34
0.001
R16
68
R17
1.2k
Q6
2SC4215
C90
15p
C89
15p
C88
0.001
D4
MA77
C17
0.001
C16
1
L14
EXCCL3225U1
C28
47p
C37
0.001
L15
18nH
R15
1.2k
R20
1k
BUFFER
AMP
R97
680
X2
CDBCA450AY24
C124
C125
10
100p
16
MIXIN
GND 15
14
C420
0.001
N-REC
N-DET 13
12
RSSI
11
IFOUT 10
QUAD
9
AFOUT
NOIS
1
2
3
4
5
6
7
8
R91
10k
R90
47
IF
IC3 TA31136FN
R19
10k
C46
18p
Q7
2SC4215
L29 33nH
PLLIN
S5V
R5V
R89
1.5k
C36
47p
L17
0.1 H
R23
4.7
C49
12p
1
VCO SW
C43
0.001
C39 18p
C50
2p
VCOS
C73
47p
R22
47k
L18
0.1 H
R25
68k
Q9
DTC144EUA
2
5
C47
0.001
C48
7p
3
R37
390
C51
0.001
L50
0.1 H
R28
68k
C23
22
C24
470p
FI4
NFE31PT152Z1E9L
C26
0.001
3.4V
C52
0.001
Q12
2SC4226
C35
0.001
YGR
C419
1.5p
R2
150
L1
32nH
TMUT
L49
0.25-1.9-9TL
3.7V
C65
470p
R36 10
(mod 38)
R14
10
R21
100
L2
44nH
T4
D8
HVC350
3.6V
R26
100
L23
0.25-1.9-9TL
C70
6p
(mod 39)
LOOP FIL
RX: 4.1V
TX: 4.2V
R33
330
R18
100
C5
0.001
VLOUT
C76
100p
L19
3.3 H
C57
12p
C42
0.001
L3
50nH
C4
0.001
T5V
C56 0.75p
R34 1.8k (mod 37)
R35
3.9k
(mod 37)
C71
0.75p
D44
HVC350
R40
100[F30G] L24 0.47 H
10[F31G]
D43
HVC350
C77
0.1 [F30G]
0.22[F31G]
C79
0.1 [F30G]
0.001[F31G]
C82
10p
C72
82p
R32
22 (mod 38)
ANT FILTER
VCC
PB4/A12/TIOCA4
R61
220k
H
R47
10k[F30G]
20K[F31G]
D45
HVC350
D6
HVC350
C431
0.001
C74
0.047
R45
10
C80
0.1
R342
1k
C372
10p
R333
1k
D40
HVC350
C78
0.001
C81
47p
L48
67nH
R39
10
R43
820[F30G]
1.5k[F31G]
R44
6.8k[F30G]
4.7k[F31G]
L25
1.8 H
20
19
18
17
16
15
14
13
12
11
VDD
TEST
LOCK
RF
RN
VDDA
PHP
PHI
VSSA
PHA
R38
2.2k C63
10
R46
4.7k[F30G]
12k[F31G]
C58
12p
C61
22p
L21
0.47 H
RX: 0V
TX: 4.8V
VCC
T5V
FIL5V
C54
470p
C55
0.01
T1
FLAC N PLL
C109
0.1
5
3
Q11
2SC4226
R30
1.8k
AFMT
4
R49
6.8k
C101
0.001
R31
3.9k
C59
47p
L20
80nH
D42
HVC350
D41
HVC350
[F30G]: IC-F30GT/ IC-F30GS
[F31G]: IC-F31GT/ IC-F31GS
[GT]: IC-F30GT/F31GT
[GS]: IC-F30GS/F31GS
AFON
2
T2
1
5
SIG2
6
SIG1
C430
0.001
L22
1.8 H
C62
10
CTCS
Q14
2SK880Y
Note
RX VCO
Q13
XP6501
TONE
C100
0.001
R50
1k
CP7
R48
10k
T3
Hz 970 mVp-p
C330
0.1
1
2
3
OUT
VDD
VSS
CD
NC
RESET
5
4
C271
0.027
C272
47p
IC19
BU4053BCFV
R376
R192 1k
100k
1
2
3
4
5
6
7
8
R330
4.7
Y1
Y0
Z1
Z
Z0
INH
VEE
VSS
VDD
Y
X
X1
X0
A
B
C
C235
22
C414
0.1
C354
0.001
Q30
2SA1362
R195
4.7k
RX: 5.0V
TX: 0.8V
C356
47p
D38
MA2S111
R197
4.7k
DC SW
R200
10k
R199
4.7k
C239
0.01
C236 C237 C238
22
22
22
+5V
16
15
14
13
12
11
10
9
RX: 0.8V
TX: 5.0V
C241
0.01
KS0
SP1
UNIVERSAL
CONNECTOR
CP1
C17
47p
CP2
KR0
KR1
KR2
KR3
PTT
S1
PTT
R375
4.7k
XTXD
MIC
PTT
9
8
7
6
5
4
3
2
1
INT MIC
MC1
EM-140
R12
33k
C25
47p
C16
0.001
Q6
CPH3403
Q8
2SC4081
R22
470k
INT SP : 0V
EXT SP: 4.8V
R21
100k
R20
470k
Q9
DTC144EUA
FRONT UNIT
11 - 1
C28
0.01
IC2
TA75S01F 5
Q7
CPH3403
R24
47k
RX: 0V
TX : 2.7V
C24
0.01
R25
180k
C413
0.1
R277 1k
C29
0.001
C355
0.001
R366
82k
6
5
1
R280 1k
C428
0.1
R284
1k
2
R362
5.6k
TX SIGNAL
D36
MA8056 M
R26
15k
C448
0.0012
C384 C385
0.001 0.1
C386
47p
G
IC17
LC73872M
VDD
NC
EST
STD
ACK
SD
LOADB
INPUT
NC
PD
OSCO
OSCI
NC
VSS
R210 390k
C248
MICO 0.018
SPCN
HV
BATTERY
GND
BDET
HV
CP3
CP4
CP5
C359
0.001
except[IS]
C358
470p
except[IS]
L53
1µH
C357
47
except[IS]
C318
0.01
R208
15k
BDET
VOXT
C249
0.018
R313
33k
R314
33k
R209
330k
C250
470p
C394
0.018
R315
33k
R207
22k
C252
470p
C251
2.2
R274
22k
C257
0.1
4
R211
1.2k
2
D29
MA2S111
IC18
TA75S01F
R212
1.8M
C352
0.039
MAIN UNIT
R177
18k
R178
27k
D47
MA8024
R179
27k
1
R140
1M
C189
0.001
C186
0.1
2
3
R139
1k
C185
0.1
TMUT
T4
L41
EXCCL3225U1
C184
10
R138
3.3k
C183
0.001
R136
6.8k C182
0.018
R134
10
C181
10
R321
2.2k
C178
100
C179
0.047
C180
47p
R222
100k
C188
47p
AF AMP
C425
0.001
C375
0.1
VLOUT
R176
56k
Q26
DTC144EUA
R153
4.7
AFON
C362
0.0012
R226
NTCG20 4M 473JT
13
C426
0.22
1
2
3
4
C407
0.1
R269
120k
R270
18k
C348
0.1
Q41
DTC144EUA
C347
0.1
A0
A1
A2
VSS
VCC
WP
SCL
SDA
R257
22k
R259
47k
C341
0.015
8
7
6
5
R258
22k
R271
220k
R266
47k
C346
0.0033
2
R272
68k
C415
2.2
R267
47k
R219 10k
C268
0.1
C338
47p
8
7
6
5
C337
47p
8
IC20A
NJM2904V
R331
470k
C295
47p
R374
47k
Q40
XP1214
1
BUSY
DTPD
2
W/N
3
C294
47P
IC30 TC7S66FU
4
Q44
DTC144EUA
C291
47p
R239
1k
C286
47p
C297
47p
C319
47p
C307
47p
C308
47p
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
C306
0.1
PE5/D5
PE6/D6
PE7/D7
PD0/D8
PD1/D9
PD2/D10
PD3/D11
PD4/D12
PD5/D13
PD6/D14
PD7/D15
CVCC
PC0/A0
VSS
PC1/A1
PC2/A2
PC3/A3
PC4/A4
PC5/A5
PC6/A6
PC7/A7
PB0/A8/TIOCA3
PB1/A9/TIOCB3
PB2/A10/TIOCC3
PB3/A11/TIOCD3
C303
47p
C302
47p
C301
47p
IC14 HD64F2238FA13
PF0/BREQ/IRQ2
PF1/BACK/BUZZ
PF2/WAIT
PF3/LWR/ADTRG
PF4/HWR
PF5/RD
PF6/AS
PF7
MD2
FWE
EXTAL
VSS
XTAL
VCC
STBY
NMI
RES
OSC1
OSC2
MD1
MD0
AVCC
VREF
P40/AN0
P41/AN1
C379
47p
C380
47p
C381
47p
R297
1k
C382
47p
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
QS
QS.
IC23
BU4094BCFV
.STR
D
CLK
OE
1
2
3
15
C378
0.1
8
EXST
SO
SCK
RESB
R224
100k
C299
47p
C300
47p
C331
47p
XTXD
SCK
SO
DAST
C333
47p
C340
47p
C339
47p
C334
47p
R250
1k
C279
0.01
NOIS
DTSD
T5C
R5C
TMUT
DDST
C309
47p
C311
47p
C312
47p
C404
47p
C405
47p
W3
D33
MA2S111
RES
CPU5V
AN0
AN1
C317
0.0047
C316
0.0047
R233
100k
Q39
2SC4116
MD2
R234
10k
C332
47p
R232
12k
R246 1k
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
PLST
PLRS
16
4
5
6
7
14
13
12
11
9
10
C277
7p
C278
0.01
C275
47p
DEST
C315 C314
47p 47p
X3
CR-681
12.288MHz
R253
100k
R252
1k
VCOS
C313
47p
R235
1k
CSFT
C280 D27
33p MA77
W2
C276
22p
12.29 MHz
3.4 Vp-p
R245
1k
R251
1k
R293
100k
C289
47p
R231
12k
C293
47p
XIN
C292
47p
XOUT
R247
1k
R240
1k
C298
47p
R329
10k
C287
47p
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
C377
47p
DUSE
R230
12k
R242
1M
C273
47p
100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
R223
220k
R244 1k
FSW
AFMT
SPCN
S5C
R332
100k
C364
47p
RDT
CB10
CB11
CB12
CB13
R243
1M
R236 1k
C288
47p
C335
47p
C325
47p
CTDA
RXDT
5
C327
47p
C328
47p
RGS2
MSKE
FCLR
4
1
2
3
C412
47p
MSO OPT12 OPT11 OPT13 OPT23 OPT21 OPT22 SDA
R237 1k
R238
1k
C326 C324
47p 47p
C320
47p
C336
47p
1
R264
470
C371
47p
KR2
KR3
R322
220k
DIN
RGS1
4
3
C305
47p
APST
R220 100k
R254
180k
R268
100
R248
1k
EXST
AUX
RDB WRB RS
C283 47p
C284 47p
C285 47p
CPU5V
REM
C342
0.1
C345
0.01
C349
0.0068
VCC
WP
SCL
SDA
A0
A1
A2
VSS
C383 0.1
IC24
HN58X2464TI
R260
47k
PTOT
RMUT
MMUT
KR0
KR1
C296
47p
R151
150k
CTCS
5
7
C351
0.1
FRCN
91
93
95
96
D5
D6
D7
RESB
R150
220k
EEPROM
1
2
3
4
C329
47p
C265 C266 C402
470p 47
47
C323 C322 C321
47p
47p 47p
C259
0.01
BEEP
C282 47p
D1
D2
D3
D4
L43
4.7µH
C264
47
IC16 HN58X2464TI
C343
820p
IC7D
NJM2902V
C262
470p
R249
1k
FRST
CCS
SCL
D0
CPU5V
R345
1k
24
23
22
21
20
19
18
17
16
15
14
13
IC13
M62364FP
8
7
6
5
R261
47k
12
14
R262
5.6k
DUSE
C253
0.001
VIN8
VOUT8
VOUT7
VIN7
GND
RESET
VDAREF
DO
VIN6
VOUT6
VOUT5
VIN5
S5V
RX SIGNAL IC20B
R273
NJM2904V
22k
5
C350
0.01
VIN1
VOUT1
VOUT2
VIN2
VDD
LD
CLK
DI
VIN3
VOUT3
VOUT4
VIN4
C258
0.1
IC27
M62334FP
R281 R182 R181
27k 27k 27k
R218
39k
6
D/A
1
2
3
4
R225
100k
C396
1
R275
22k
C424
470p
C410
0.1
C443
0.001
R316
2.7k
C395
68p
1
2
3
4
5
6
7
8
9
10
11
12
R324
470
S5V
R5V
5
3
C411
4.7
14
13
12
11
10
9
8
Q43
2SC4116
VOX
1
C247
10
R157
22k
R312
22k
D/A
R354
3.9k
R221 33k
C246
0.001
C244
0.001
C243
47
1
2
3
4
5
6
7
R216
100k
[GT] only
I
S5V
R5V
R206 100
DSIN
C260
0.001
IC12
AN8005M
R368
390k
C449
0.1
R215
1M [GT]
100k [GS]
7.5V
DTMF DECODE
+5V
R27
12k
[GT]: IC-F30GT/F31GT
[GS]: IC-F30GS/F31GS
C450
0.1
C254
4.7
DSIN
C30
0.1
C242
4.7
L45
1.8µH
4
C393
1
D35
MA8056 M
R344
1k
REG
R202
1k
3
0.9V
R367
1.5k
5
2
R369
180k
C452
0.1
D34
MA8056 M
1
C447
820p
MD2
D30
MA8062 M
IC31
TC75S51F
4
R201
2.2k
3
RES
XRXD
XTXD
RX: 0V
TX : 2.2V
Note
R364
100k
C353
0.001
1
3
2
R325
10k
R279 1k
C429
47p
4
C27
270p
R278
1k
R365
39k
C445
0.022
R276
47
AFOUT
3.58 MHz
2.8 Vp-p
5.0V
Q32
2SB1132
O
RX SIGNAL
R363
100k
SPCN
R285 10k
C451
47p
W3
R23 10k
INT SP: 0V
EXT SP: 4.3V
PTT
SP+
MIC+
R203
10k
S5V
MP6
AFO
VCC
DETECT
MICE
RESET
XRXD
C15
47p
Q33
XP6501
C240
0.01
C446 820p
INT SP
C453
15p
C195
470p
VCC
CPU5V
+5V
R198
10k
R196
10k
C200
56p
6
R155
39k
C444
330p
C187
47p
5
7
R69
100k
10
NC
POUT
9
PWGND
VCC
NC
PREGND 8
VIN
PHASE 7
NF 6
RIPPLE
R135
10
P30/TXD0
VCC
F1
KAB
2402322NA29
C434
0.1
Q31
2SA1362
Q29
2SA1362
R163
33k
C173
0.01
VAG
C408
0.1
C409
0.1
VCC
T5V
D31
MA2S111
R343
1k × 2
5.0V
AFVI
HV
C199 R159
120p 100k
R161
68k
9 C202
270p
P76/RXD3
P77/TXD3
P36
P35/SCK1/SCL0
P34/RXD1/SDA0
P33/TXD1/SCL1
P33/SCK0/SDA1
P31/RXD0
VCC
C263
0.1
R162
68k
10
8
R137
2.7k
D26
MA2S111
C174
0.001
AFOUT
5.0V
S5V
+5V
R5V
R217
470
R227
100k
IC7B
NJM2902M
IC7C
NJM2902M
R349
1k
C281 R229
0.1 100k
R292
5.6k
16
15
14
13
12
11
10
9
4
R133
2.2k
CPU5V
C433
47p
RX: 5.0V
TX: 0V
RX: 0V
TX: 5.0V
C400
0.001
VDD
Y
X
X1
X0
A
B
C
95
Q46
DTC144EUA
C197
0.01
X4 CR-563
3.579545 MHz
D46
MA742
R152
150k
Y1
Y0
Z1
Z
Z0
INH
VEE
VSS
5
R132
180k
C440
0.001
IC5 TA7368F
1
2
3
4
5
C458
0.1
C304
47p
R291
100k
IC15
S-80942CNMC-G9C
R299
1k
SENC
CTDA
SDEC
RXDT
AFVI
VOXT
LVIN
RSSI
S10
R298
100k
C261
0.1
1
2
3
4
5
6
7
8
VAG
MICI
C432
0.1
R190
100k
C205
0.1
C456
0.1
R372
33k
R336
100k
R318
33k
C172
4.7
C171
0.01
Q24
XP6501
P13/TIOCD0/TCLK
P14/TIOCA1/IRQ0
P15/TIOCB1/TCLK
P16/TIOCA2/IRQ1
P17/TIOCB2/TCLK
AVSS
P97/DA1
P96/DA0
P47/AN7
P46/AN6
P45/AN5
P44/AN4
P43/AN3
P42/AN2
S11
C421
0.1
C401
47p
AF VR R193
10k
C454
18p
C208
4.7
VAG
PTIN
CB10
CB11
CB12
CB13
INT SP SW
C207
0.1
C213
4.7
C214
0.1
R180
15k
IC9
TC35453F
EXPIN
EXPGS
ECHG
EXPO
PWRIN
PWRGS
PWRON
PWROP
MSKST
VSSA
VSSD
R228
100k
C406
0.022
C198
0.0047
C121
0.1
6
1
5
R131
330k
AF ON : 7.5V
AF OFF: 0V
RX: 0V
TX: 5.0V
R130
10k
3
4
C442
4.7
D39
MA8030H
D25
MA77
MMOD
RTM
DTAC
TRD
ADSL
C367
47p
C455
0.1
C224
R370 0.1
47k
R371
22k
R373
4.7k
C215
0.1
MICIN
MICGS
CALO
ALCO
CMPIN
CCHG
CMPO
TXFI
VDDA
VDDD
STB
R165
47k
44
43
42
41
40
39
38
37
36
35
34
IC29
BU4053BCFV
PG3/CS1
PG2/CS2
C366
47p
R166
10k
+5V
2
R328
1k
C170
9p
R141 68k
XRXD
SI
S12
C232
0.0022
Q47
2SC4116
B
MCOT
MCIN
AFOUT
C234
47p
R173
150k
11
C203
0.0022
12
13
14
15
16
17
18
19
20
21
22
C219 120p
VAG
R288
10k
R188
100k
L47
1.0µH
SENC
S16
1
C206 0.1
C193
2.2
R175
5.6k
C218
0.0047
D24
MA77
Q22
DTA144EUA
R129
3.9k
IC4
TC75S51F
APC
Q23 2SB1132
AF REG
VCC
96
VCC
VCC
SPCN
S1
EC10SP16-47
1 3
1 C1 2 4
2
5
C2 4 6
8
D3
MA6S121
C162 R125
0.001 10k
MSCK
93
Q45
UN911H
3
AF FIL
R184
12k
R185
120k
C230
10
+5V
4
C437
6p
C168
8p
PA0/A16
PA1/A17/TXD2
PA2/A18/RXD2
PA3/A19/SCK2
+5V
POWER
C14
47p
RX: 2.6V
TX: 0V
C147
0.001
R327
47
L51
56nH
R126
100k
R115
10k
L40
47nH
L39
47nH
D23
MA2S111
L38
56nH
C165
4p
C161
0.001
VCC
R164 220k
C177
470p
R128 100k
R127
100
C167
6p
PB5/A13/TIOCB4
PB6/A14/TIOCA5
PB7/A15/TIOCB5
R289
100k
C225
0.047
IC7A
NJM2902V
2
R186
68k
AUDIO
PROCESSOR
C217
0.1
C233
0.1
KS1
C146
0.001
R116
100k
R117
270
SIG2
D0
R10
1.5k
R9
220
C160
7p
SIG1
C310
47p
C231
0.0047
4.7k
Q27
2SC4213
R189
470
PTOT
C398 0.0047
C226
0.047
C227
0.033
R167 470k
C176
0.001
D2
MA713
RX BPF
D21
HVC350
ULCK
S107
D22
MA2S111
PE4/D4
PE3/D3
PE2/D2
PE1/D1
PE0/D0
PG4/CS0
S108
R11
3.3k
R124
Q21 470k
2SK1829
D20
HVC350
L37
56nH
CTCS
R187
G
PTIN
R323
100k
C365
47p
Q2
2SC4116
C159
0.001 R122
1.8k
PB4/A12/TIOCA4
S109
DS15
LN1371G[GS] only
C142
0.001
C139
0.001
C154
47p
TONE
DSIN
C192
0.0047
R183
1.5k
SDEC
S112
C13
47p
LED OFF: 0V
LED ON : 5.0V
DS9
LN1371G[GT] only
D2
MA111
KS2
Q5
DTC
144TE
R112 10k
C155
0.001
C9
22p
C175
0.1
C163
1p
C156
5p
R119
390k
R334
4.7k
R113
220k
R114 10k
R111
150k
W/N
RX: 5.0V
TX: 0V
S5C
DS8
LN1371G[GT] only
C12
47p
C138
0.001
R171 68k
R174
27k
D19
HVC350
C141 C143
0.001 7p
AN0
RESB
VCC
KR0
KR1
KR2
KR3
FRST
R5C
S104
C137
6p
AN1
A
T5C
S105
L52
L33
0.1µH 56nH
RX: 0.9V
TX: 0V
MOD
C457
100p
R317
C399 470k
0.0047
C397
0.0047
R172
68k
C216
0.047
R168
39k
FSW
S106
R103
220
C145
0.001
D18
HVC350
C135
5p
R105
C134 4.7k
0.001
MAPD
C228
470p
DSIN
S111
FI1
FL-322
31.650 MHz
6 5 4 3
MMOD
C229
47p
CH SELECT
KS3
KS2
KS1
KS0
KR0
KR1
KR2
KR3
MIC+
SPCN
SP+
PTT
KS3
Q19
3SK206
C128
7p
R352 10k
RDB
WRB
RS
R14
100k
DS12
DS7
LN1371G- LN1371G[GT] only [GT] only
C116
470p
C122
47p
C130
0.001
C140
1.5p
C158
47p
R1
82k
C416
10p
R5 4.7k
R123
47k
R118
100k
Q20
3SK293
C1
33p
R121
4.7
R120
15k
RX: 3.9V
TX: 0V
RX BPF
R360
470
R359
470
R3
2.2k
R6 4.7k
S5V
MCOT
MCIN
DS14
LN1371G[GS] only
R93
47k
L42
1.8µH
Q18
2SC4215
R102
270
1
C133
0.001
C438
0.001
C2
33p
D1
MA77
C29
0.001
C157 0.47
L36
56nH
C3
18p
C8
0.001
L5
50nH
C12
22p
C441 R4
47p 2.2k
C14
56p
Q1
2SK2974
C20
0.001
R8
18k
T1
RX: 4.6V
TX: 0.1V
R92
47k
C422
0.1
R94
3.3k
C118
0.001
2
R358
12
C151
0.001
C6
0.001
C403
0.001
L7
7.5nH
AFMT
C111
220p
R87
3.9k
Q17
2SC4116
C115
0.001
R95
4.7
C119
0.001
C132
0.01
L31
0.82µH
C131
27p
MCF
R99
1k
C369
8p
C30
0.1
R7
22
CIRQ
91
R85
330
R340
180k
R98
100k
C120
0.001
C117
0.001
MIXER
L10
25nH
L8
15nH
PG1/CS3/IRQ7
PG0/IRQ6
P70/TMRI01
P71/TMRI23
P72/TMO0/CS6
P73/TMO1/CS7
P74/TMO2/MRES
P75/TMO3/SCK3
Q16
DTA144EUA
C114
0.1
C360
1
C22
0.001
P10/TIOCA0/A20
P11/TIOCB0/A21
P12/TIOCC0/TCLK
R88
47k
RF AMP
C150
47p
TO ANTENNA
MP3
C31
0.1
RF AMP
CP1
C417
10p
L4
4.7µH
RX: 0V
TX: 2.8V
C149
470p
C148 R110
0.001 4.7k
C18
0.001
C19
150p
Q2
2SK2973
R10
68
R12
10k
C38
0.001
T2
C423
0.1
C123
100p
C127
2.2
R109
100
T4
C112
220p
C126
470p
R16
68
L13
18nH
L1
32nH
C418
5p
CP2
FINAL
PRI AMP
C34
0.001
R17
1.2k
C27
0.001
L2
44nH
C419
1.5p
R2
150
L9
EXCCL3225U1
C7
47p
C21
470p
Q3
2SC4226
D5
MA77
C90
15p
C89
15p
C88
0.001
D4
MA77
Q6
2SC4215
T3
OUT
VCC
R86
82k
C267
0.01
MMUT
10
9
8
7
6
5
4
3
2
1
C18
47p
R75
100k
D14
DAP202U
C53
47p
ADSL
IC1
TC74VHC373FT
S101
C110
0.1
RMUT
D7
D6
D5
D4
D3
D2
D1
R63
56
C37
0.001
L15
18nH
C17
0.001
C16
1
L14
EXCCL3225U1
C28
47p
R15
1.2k
R20
1k
BUFFER
AMP
L29 33nH
PLLIN
C46
18p
Q7
2SC4215
BDET
S102
+5V
Q8 2SC4215
MSCK
MSO
S103
KS4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
R80
22k
R79
12k
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
R361
470
R96
3.9k
R19
10k
L35 1µH
L44
1µH
SPLO
S110
DS6
DS11
LN1371G- LN1371G[GT] only [GT] only
R82
15k
R78
22k
R77
15k
R73
100k
1
2
3
4
5
6
7
8
C113
0.01
3
C124
C125
10
100p
16
MIXIN
15
GND
14
C420 0.001
N-REC
N-DET 13
12
RSSI
11
IFOUT 10
QUAD
9
AFOUT
C36
47p
L17
0.1µH
R23
4.7
C49
12p
1
R29
10k
C43
0.001
C39 18p
R97
680
X2
CDBCA450AY24
C26
0.001
S5V
MOD
F0
D1
MA111
R347
4.7
CCS
CIRQ
R91
10k
R90
47
IF
IC3 TA31136FN
R22
47k
L18
0.1µH
C50
2p
VCO SW
SQIN
S2
F1
SCK
SO
R89
1.5k
D16
DAN202U
3
R81
FI3 SFPCA450KG1A 4.7
2
1
R25
68k
C48
7p
3
5
C51
0.001
C23
22
C24
470p
FI4
NFE31PT152Z1E9L
C47
0.001
Q9
DTC144EUA
VCOS
SCL
SDA
S3
F2
11
12
13
14
15
16
17
18
19
20
S4
F3
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
R24
220
L50
0.1µH
R28
68k
2
RX: 0V
TX: 4.9V
RTM
RDT
RESB
VCC
S5
FI2 SFPCA450KE4A
2
1
D15
DAN202U
FCLR
R17
100k
GND
+5V
D7
D6
D5
D4
D3
D2
D1
SPCN
RDB
WRB
RS
GND
RESB
VCC
KR0
KR1
KR2
KR3
FRST
MIC+
D0
SP+
PTT
GND
TX VCO
C73
47p
DAST
SCK
SO
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
D7
D6
D5
D4
D3
D2
D1
D0
RDB
WRB
RS
C376
0.001
4
R37
390
YGR
L3
50nH
C4
0.001
C5
0.001
C35
0.001
3.4V
S5V
R5V
W/N FILTER
E
D13
DAP202U
R355
47k
Q10
XP1214
R14
10
R21
100
C52
0.001
C66
0.5p
L46
3.3µH
S5V
R5V
C
J3
W5
R356
180k
MSKE
TRD
0V
J1
RX: 0V
TX: 5.0V
Q15
2SC4116
VCOS
SI
C2
0.1
C84
12p
R42
100k
×3 MULTI
T4
T3
T2
T1
C22
0.1
R66
OPV21 47k
C85
2.5p
C86
5p
C67
12p
D7
1SV245
R41
220k RX: 2.3V
TX: 2.4V
RX: 2.6V
TX: 2.5V
C64
0.001
Q12
2SC4226
C68
18p
R18
100
3.6V
3.7V
C65
470p
R36 10
(mod 38)
C69
22p
C373
10p
11
10
9
8
7
6
5
4
3
2
1
f =41 kHz
5V
R4
820k
C23
1
RGS2
C82
10p
CST
AGND
TXFO
IDCIN
IDCGS
TXOUT
MSKIN
MSKGS
RXIN
RXGS
RXFO
C4
1
R65
OPV22 47k
C87
3p
L26
1.8µH
DIN
DCK
REGS1
REGS2
XOUT
XIN
MSKE
TRD
RTM
RDT
FCLR
C1
0.1
C3
0.1
MSKE
L27
1.8µH
D8
HVC350
L49
0.25-1.9-9TL
RX: 4.1V
TX: 4.2V
R33
330
ANT FILTER
T5V
C42
0.001
R26
100
L23
0.25-1.9-9TL
C70
6p
(mod 39)
LOOP FIL
C77
0.1 [F30G]
0.22[F31G]
C79
0.1 [F30G]
0.001[F31G]
D44
HVC350
L19
3.3µH
C57
12p
[F30G]: IC-F30GT/ IC-F30GS
[F31G]: IC-F31GT/ IC-F31GS
[GT]: IC-F30GT/F31GT
[GS]: IC-F30GS/F31GS
VCC
C56 0.75p
R34 1.8k (mod 37)
R35
3.9k
(mod 37)
C71
0.75p
R40
100[F30G] L24 0.47µH
10[F31G]
D43
HVC350
C76
100p
C72
82p
D6
HVC350
23
24
25
26
27
28
29
30
31
32
33
C20
47p
C8
1
C10
1
R2
1.5k
R3
22
L28
1.8µH
C439
0.001
R47
10k[F30G]
20K[F31G]
C81
47p
R61
220k
D45
HVC350
DIN
SCK
RGS1
RGS2
R18
100k
R64
47k
OPV23
BEP2
R62 C83
1.2k 0.01
C78
0.001
C80
0.1
R342
1k
C431
0.001
C74
0.047
R45
10
TONE
R5
820k
D4
C26 MA111
0.1
FCLR
C98
0.01
20
19
18
17
16
15
14
13
VSSA 12
PHA 11
VDD
TEST
LOCK
IC1
RF
RN
SA7025 VDDA
PHP
DK-T
PHI
C372
10p
R32
22 (mod 38)
RX: 0V
TX: 4.8V
VCC
T5V
FIL5V
C54
470p
C55
0.01
C58
12p
R333
1k
D40
HVC350
R43
820[F30G]
1.5k[F31G]
R44
6.8k[F30G]
4.7k[F31G]
L25
1.8µH
BEP2
C9
1
Q4
DTC144TE
R1
3.3k
C97
47p
R67
100k
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
R46
4.7k[F30G]
12k[F31G]
L48
67nH
R39
10
Q11
2SC4226
R30
1.8k
C61
22p
L21
0.47µH
BEP1
R7
560k
SIG2
OPT21
OPT22
OPT23
Q1
2SC4116
C96
47p
CLOCK
DATA
STROBE
VSS
RFIN
RFIN
VCCP
REFIN
RA
AUXIN
3
BEEP
C7
1
C95
47p
C108 R59 C91
47p 2k 47p
1
2
3
4
5
6
7
8
9
10
4
R31
3.9k
C59
47p
L20
80nH
D42
HVC350
D41
HVC350
R38
2.2k C63
10
APST
C11
1
PTOT
Q3
DTC144TE
C19
0.1
R6
390k
R307
100k
C99 47p
2
DDST
DTAC
DTSD
C21
1
F
REM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
R57
2k
SCK
SO
PLST
ULCK
D
To optional unit
OPT2 J2
DS1
LNJ310M6URA
10.3V
C109
0.1
LVIN
R58 1k
1
5
FLAC N PLL
W4
2
6
L22
1.8 µH
C62
10
R49
6.8k
C101
0.001
PLRS
AFON
DS5
LNJ210C6ARA
SQL CLOSE: 0V
SQL OPEN : 5.0V
5.0V
C6
1
DS13
LNJ310M6URA
1
SQIN
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
DS4
LNJ310M6URA
DS2
LNJ310M6URA
J2
R53
220k
2
C430
0.001
Note
RX VCO
Q13
XP6501
RSSI
13.1V
R8
560
3
C102
0.0047
R51
10k
Q14
2SK880Y
MICO
R13
330
4
CP7
C103
10p
C100
0.001
R50
1k
LV
X1
CR-667
15.600 MHz
DTPD
NC
NC
V0
V1
V2
V3
V4
VS/TE
RESB
CSB
RS
M/S
M86
P/S
SCL
WRB
RDB
D0
D1
D2
D3
D4
D5
D6
D7
OSC0
OSC1
VSS
PMODE
VDD
VEE
CAP–
CAP+
VEE2
VEE3
VOUT
VR1
VR2
NC
NC
LCD
IC2
TC75S51F
5
3
R48
10k
NOIS
DS10 EDMMUD1FA0
R52 100
4
C104
0.1
1
C107
47p
FRCN
+5V
BEP1
D10
DAN202U
C105
0.001
R54
100
R55 22k
SPLO
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
R341
27k
C106
0.1
R296
47k
To optional unit
OPT1 J1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
C427
4.7
195
R.FIL
REF
GND
OPV11
OPV12
OPV13
195
15.6 MHz 970 mVp-p
VCC
T5V
S5V
+5V
VCON
R294 47k
R295 47k
DS3
LNJ310M6URA
BUSY
AUX
SIG1
OPT11
OPT12
OPT13
APST
DIN
RGS1
R60
100k
VOLTAGE DIAGRAM
195
UP
W/N
SECTION 11
VOLTAGE DIAGRAM
PLLIN
IC-F30GT/GS
210
C330
0.1
1
2
3
OUT
VDD
VSS
CD
NC
RESET
5
4
C271
0.027
C272
47p
INTRODUCTION
This service manual describes the latest service information for
the IC-F30GT/GS and IC-F31GT/GS VHF TRANSCEIVER at
the time of publication.
To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than 10 V. This will ruin the
transceiver.
DO NOT expose the transceiver to rain, snow or any liquids.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100
mW) to the antenna connector. This could damage the
transceiver’s front end.
INTERINSICALLY SAFE QUALIFICATION
When servicing intrinsically safe versions of the IC-F30GT/GS
and IC-F31GT/GS the following conditions must be met.
Failing to satisfy any of these conditions will invalidate the
INTRINSICALLY SAFE certification.
1. Servicing the transcever should only be undertaken by
suitably qualified personnel in a non-hazardous area.
Never attempt to remove the case in a hazardous area.
2. ONLY the approved battery, ICOM’s BP-210FM may be
used.
3. USE ONLY safety critical components as specified in the
parts list (SECTION 6), should replacement of any item
be necessary.
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : 06 6793 5302
Fax
: 06 6793 0013
URL : http://www.icom.co.jp/world/index.html
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1. 10-digit order numbers
2. Component part number and name
3. Equipment model name and unit name
4. Quantity required
< Corporate Headquarters >
IC-F30GS
IC-F31GS
IC-F30GT
IC-F31GT
<SAMPLE ORDER>
1110001810 S.IC TA7368F
8930053170 2337 Key board
IC-F30GT
IC-F31GS
MAIN UNIT 1 piece
CHASSIS
5 pieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1. Make sure a problem is internal before disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is disconnected from its power source.
3. DO NOT force any of the variable components. Turn them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the transceiver is defective.
6. DO NOT transmit power into a signal generator or a sweep generator.
7. ALWAYS connect a 40 dB or 50 dB attenuator between the transceiver and a deviation meter or spectrum analyser when
using such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : (425) 454-8155 Fax : (425) 454-1509
URL : http://www.icomamerica.com
< Customer Service >
Phone : (425) 454-7619
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : (604) 952-4266 Fax : (604) 952-0090
URL : http://www.icomcanada.com
Communication Equipment
Himmelgeister Str. 100, D-40225 Düsseldorf, Germany
Phone : 0211 346047 Fax : 0211 333639
URL : http://www.icomeurope.com
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
Phone : (93) 590 26 70 Fax : (93) 589 04 46
URL : http://www.icomspain.com
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : 01227 741741 Fax : 01227 741742
URL : http://www.icomuk.co.uk
A.B.N. 88 006 092 575
290-294 Albert Street, Brunswick, Victoria, 3056, Australia
Phone : 03 9387 0666
Fax : 03 9387 0022
URL : http://www.icom.net.au
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : 09 274 4062
Fax : 09 274 4708
URL : http://www.icom.co.nz
Zac de la Plaine, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
Phone : 561 36 03 03 Fax : 561 36 03 00
URL : http://www.icom-france.com
6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : (02) 2559 1899 Fax : (02) 2559 1874
iC-f30gt
ic-f30gs
iC-f31gt
ic-f31gs
VHF TRANSCEIVER
iC-f30gt
iC-f30gs
iC-f3 1 gt
iC-f3 1 gs
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-13805MZ-C1-w
© 2001 Icom Inc.

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download IC-F30G Service manual