Download Samsung SGH-F490 service manual

GSM TELEPHONE
SGH-F490
GSM TELEPHONE
CONTENTS
1.
Safety Precautions
2.
Specification
3.
Product Function
4.
Array course control
5.
Exploded View and Parts List
6.
Main Electrical Parts List
7.
Block Diagrams
8.
PCB Diagrams
9.
Flow Chart of Troubleshooting
10.
Reference data
11.
Disassembly and Assembly
Instructions
GSPN (Global Service Partner Network)
Country
North America
Latin America
CIS
Europe
China
Asia
Mideast & Africa
Web Site
service.samsungportal.com
latin.samsungportal.com
cis.samsungportal.com
europe.samsungportal.com
china.samsungportal.com
asia.samsungportal.com
mea.samsungportal.com
This Service Manual is a property of Samsung Electronics Co.,Ltd.
Any unauthorized use of Manual can be punished under applicable
International and/or domestic law.
ⓒ Samsung Electronics Co.,Ltd.
2008. 01 Rev.1.0
1. Safety Precautions
1-1. Repair Precaution
● Repair in Shield Box, during detailed tuning.
Take specially care of tuning or test,
because specificity of cellular phone is sensitive for surrounding interference(RF noise).
● Be careful to use a kind of magnetic object or tool,
because performance of parts is damaged by the influence of magnetic force.
● Surely use a standard screwdriver when you disassemble this product,
otherwise screw will be worn away.
● Use a thicken twisted wire when you measure level.
A thicken twisted wire has low resistance, therefore error of measurement is few.
● Repair after separate Test Pack and Set because for short danger (for example an
overcurrent and furious flames of parts etc) when you repair board in condition of
connecting Test Pack and tuning on.
● Take specially care of soldering, because Land of PCB is small and weak in heat.
● Surely tune on/off while using AC power plug, because a repair of battery charger is
dangerous when tuning ON/OFF PBA and Connector after disassembling charger.
● Don't use as you pleases after change other material than replacement registered on SEC System.
Otherwise engineer in charge isn't charged with problem that you don't keep this rules.
1-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Safety Precautions
1-2. ESD(Electrostatically Sensitive Devices) Precaution
Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD
(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.
You can prevent from ESD damage by static electricity.
● Remove static electricity remained your body before you touch semiconductor or parts with
semiconductor. There are ways that you touch an earthed place or wear static electricity
prevention string on wrist.
● Use earthed soldering steel when you connect or disconnect ESD.
● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by
static electricity.
● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and
aluminum plate to have conductive power,they are prevented from static electricity.
● You must maintain electric contact between ESD and place due to be set up until ESD is connected
completely to the proper place or a circuit board.
1-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
2. Specification
2-1. GSM General Specification
EG SM 9 00
DCS 1800
PCS 1900
WCDMA2100
Fr eq.
Band[MHz]
Uplin k/Down link
8 80~915
9 25~960
17 10~178 5
18 05~188 0
18 50~191 0
19 30~199 0
192 0~1980
211 0~2170
ARF CN ra nge
0~124 &
97 5~1023
5 12~885
5 12~810
UL:96 12~988 8
DL:105 62~108 38
T x/Rx spacing
45MHz
95MHz
80MHz
1 90MHz
Mo d. Bit r ate/
Bit Period
270 .833kb ps
3 .692u s
270 .833kb ps
3 .692u s
270 .833kb ps
3 .692u s
3.8 4Mcps
Ti me Slo t
Pe rio d/Fr am e
Per iod
5 76.9u s
4. 615ms
5 76.9u s
4. 615ms
5 76.9u s
4. 615ms
Fr ame len gth : 10ms
Slot length : 0.6 67ms
Modula tion
0 .3G M SK
0 .3G MSK
0 .3G M SK
Q PS K
HQPSK
MS Power
33d Bm~5dBm
30d Bm~0dBm
30d Bm~0dBm
24 dBm~ - 50dBm
Powe r Class
4
(max +33dBm)
1
(max +30dBm)
1
(max +30dBm)
3
(max +24dBm)
Se nsitivity
-10 2dBm
-10 0dBm
-10 0dBm
-1 06.7d Bm
TDMA Mu x
8
8
8
NA
Cell Radiu s
35Km
2Km
2Km
2Km
2-1
Speclflcation
2-2. GSM Tx Power Class
TX Power
control level
GSM900
TX Power
control level
DCS1800
TX Power
control level
PCS1800
5
33±2 dBm
0
30±3 dBm
0
30±3 dBm
6
31±2 dBm
1
28±3 dBm
1
28±3 dBm
7
29±2 dBm
2
26±3 dBm
2
26±3 dBm
8
27±2 dBm
3
24±3 dBm
3
24±3 dBm
9
25±2 dBm
4
22±3 dBm
4
22±3 dBm
10
23±2 dBm
5
20±3 dBm
5
20±3 dBm
11
21±2 dBm
6
18±3 dBm
6
18±3 dBm
12
19±2 dBm
7
16±3 dBm
7
16±3 dBm
13
17±2 dBm
8
14±3 dBm
8
14±3 dBm
14
15±2 dBm
9
12±4 dBm
9
12±4 dBm
15
13±2 dBm
10
10±4 dBm
10
10±4 dBm
16
11±3 dBm
11
8±4dBm
11
8±4dBm
17
9±3dBm
12
6±4 dBm
12
6±4 dBm
18
7±3 dBm
13
4±4 dBm
13
4±4 dBm
19
5±3 dBm
14
2±5 dBm
14
2±5 dBm
15
0±5 dBm
15
0±5 dBm
2-2
3. Product Function
Main Function
▪ Full Touch Screen
▪ Bluetooth Class 2
▪ Extended GSM 900MHz & DCS1800MHz & PCS1900MHz
&WCDMA/HSDPA2100MHz Quad Band
▪ Bar type
▪ Color LCD (262K TFT colors, 3.2", 240 x 432)
▪ Built-in 5Mega pixel and QCIF Camera
▪ Built-in MP3 Player
▪ GPRS Multi-slot Class 12
▪ Downloadable Game via JAVA
▪ 64 Polyphonic Ring Tone
▪ Sending Photo & Video by MMS or E-Mail
▪ VideoTelephony
▪ External Memory Card Socket (T-flash)
▪ 1000mAh Battery
3-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Product Function
3-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
4. Array course control
4-1. Software Adjustments
1. JIG(GH80-03308A): Download, Trace, Calibration, etc
2. 0.4M Test cable(GH39-00886A): JIG to phone
3. 1.5M Test cable(GH39-00889A): JIG to phone
4-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4.Travel Adaptor(GH44-01702A)
5.Data Link Cable(GH39-00922A): USB cable
6.Serial cable(LJ39-00013A) : PC to JIG
4-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
7. RF test cable(GH39-00397A): RF test
4-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4-2. Software Downloading
4-2-1. Downloading Binary Files
•Four binary files for downloading F490
–amss_compressed : Modem binary for communication function and
user interface and various application
–Rsrc_F490_Open_Europe_Common.rc1: Files need for each application
–Rsrc2_F490(Low).rc2 : Power on/off animation
–FactoryFs_F490_Open_Europe_Common.ffs :
Default file system to be put into in initial production
4-2-2. Pre-requsite for Downloading
•Downloader Program (MultiLoader V5.30)
•SGH-F490 Mobile Phone
•USB Data Link Cable
•Binary files
4-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4-2-3. S/W Downloader Program
1. Boot the F490 by pressing 'power ON' + 'Camera hot key' + 'Volume Up Key' at
the same time.
If you do properly, you can see the following message on Main LCD "Download"
2. Load the binary download program by executing the "MultiLoader V5.30.exe".
And the Check the MSM6245/MSM6260
4-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
3. Select the check box what you want to download.
4-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4. Select the binary file what you want to download
* Up to eight ports are supported.
4-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
5. Now press the button 'DownLoad'.
6. When downloading is complete, UE reboot automatically.
-If there is difference in FactoryFS.bin, UE will format file system automatically.
4-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
5. Exploded View and Parts List
5-1. Cellular phone Exploded View
QME03
QFR01
QLC01
QMI01
QPC01
QLB01
QCA01
QMO01
QMP01
QSP01
QCA02
QVK02
QCB01
QVK01
QME32
QAN02
QSH01
QCR04
QCR03
QRF03
QCK02
QCK01
QRE01
QIF01
QVO01
QCR04
QDC01
QCR04
QRF01
QBA01
QBA00
QBA02
QST08
5-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View and Parts List
5-2. Cellular phone Parts List
Design LOC
QAN02
QBA00
QBA01
QBA02
QCA01
QCA02
QCB01
QCK01
QCK02
QCR03
QCR04
QCR04
QCR04
QFR01
QLB01
QLC01
QME03
QME32
QMI01
QMO01
QMP01
QPC01
QRF01
QSH01
QSP01
QST08
QVK01
QVK02
QVO01
QRE01
QDC01
QIF01
QRF03
Description
SEC CODE
INTENNA-SGH F490
PMO CASE-BATT
INNER BATTERY PACK-1000MAH,BLK
PMO CASE-BATT V2
CAMERA MODULE-SGH F490
KEY FPCB-CAM KEY FPCB ASS'Y
COAXIAL CABLE-SGHE490 ANT CABL
PMO KEY-CAMERA
PMO KEY-HOLD
SCREW-MACHINE
SCREW-MACHINE
SCREW-MACHINE
SCREW-MACHINE
ASSY CASE-FRONT
ASSY BRACKET-LCD
LCD-SGH F490MODULE
UNIT-TOUCH PANEL
UNIT-FLASH FPCB
MICROPHONE-ASSY-SGH F490
MOTOR LINEAR VIBRATION-SCH F49
PBA MAIN-SGH F490
FPC-SLIDE FPCB
TAPE-SHEET RF
ICT SHIELD-COVER
SPEAKER
ASSY ACCE-STYLUS PEN
KEY FPCB-VOLUME KEY
ASSY ETC-SGH-F490 EARJACK FPCB
PMO KEY-VOLUME
ASSY CASE-REAR
ASSY DECO-CAMERA
PMO COVER-IF
PMO COVER-EAR
GH42-01406A
GH72-44834A
GH43-02974A
GH72-46238A
GH59-05166A
GH59-05137A
GH39-00674A
GH72-46638A
GH72-46639A
6001-001811
6001-001479
6001-001479
6001-001479
GH98-06647A
GH98-06649A
GH07-01250A
GH59-05361A
GH59-05136A
GH30-00449A
GH31-00401A
GH92-04207A
GH41-01945A
GH74-36524A
GH70-03077A
3001-002281
GH98-02835H
GH59-05121A
GH59-05163A
GH72-46637A
GH98-06648A
GH98-06650A
GH72-46635A
GH72-46636A
5-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View and Parts List
Description
SEC CODE
IC-MEMORY CARD
CBF INTERFACE-DLC APCBS10BBE(S
CBF INTERFACE-MIC CABLE(S20P,T
ADAPTOR-ATADS10EBE,BLK,EU
S/W CD-SGHF490PC STUDIO CD
UNIT-EARPHONE(BLK)
LABEL(P)-UNIT SEAL
LABEL(R)-WATER SOAK
LABEL(P)-OPEN MP3
MANUAL USERS-EU FRENCH
LABEL(R)-MAIN(FRAN)
BOX-UNIT(EU)
BOX-SLIP CASE(EU_NEW)
RMO RUBBER-LED BLOCK
VINYL-BOHO TSP
TAPE INSU-IF CONN
VINYL-BOHO MAIN
SPONGE-MEGA CAM
ASSY PACKING-HAAXEF(BEA/FRAN)
ASSY ACCE-PHONE POUCH
CBF SIGNAL-SPHA560 RF CABLE
CBF INTERFACE-SGH-L760 TEST CA
CBF INTERFACE-SGH-L760 TEST CA
INSTALL-TEST JIG BOX
1109-001363
GH39-00922A
GH39-00948F
GH44-01702A
GH46-00598A
GH59-02261A
GH68-00518B
GH68-09361A
GH68-11246A
GH68-17275A
GH68-17280B
GH69-06359A
GH69-06454A
GH73-11374A
GH74-36523A
GH74-37028A
GH74-37232A
GH74-37442A
GH95-01298A
GH98-07723A
GH39-00397A
GH39-00886A
GH39-00889A
GH80-03308A
5-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View and Parts List
5-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
6. MAIN Electrical Parts List
SEC Code
Design LOC
Description
STATUS
0403-001547
0404-001172
0406-001215
0406-001215
0406-001237
0406-001237
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001254
0406-001275
0407-001002
0504-001113
0801-003016
1001-001336
1001-001405
1001-001428
1001-001428
1001-001428
1001-001428
1001-001436
1001-001481
1003-002047
1108-000151
1201-002190
1201-002531
1201-002570
1201-002610
1202-001068
1203-003523
1203-003523
1203-003737
1203-003815
1203-004339
1203-004340
1203-004340
1203-004453
D700
D703
D701
D702
D600
D601
D704
D705
D707
D708
D709
ZD500
ZD501
ZD502
ZD503
ZD504
ZD700
ZD701
ZD702
ZD703
ZD704
ZD705
ZD401
D400
TR400
U601
U704
U301
U504
U505
U506
U702
U510
U302
U703
UME300
U501
PAM101
PAM100
U500
U502
U406
U408
U409
U701
U403
U402
U404
U407
DIODE-ZENER
DIODE-SCHOTTKY
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-ARRAY
TR-DIGITAL
IC-CMOS LOGIC
IC-ANALOG SWITCH
IC-ANALOG MULTIPLEX
IC-ANALOG MULTIPLEX
IC-ANALOG MULTIPLEX
IC-ANALOG MULTIPLEX
IC-ANALOG MULTIPLEX
IC-ANALOG SWITCH
IC-ANALOG SWITCH
IC-MOTOR DRIVER
IC-MCP
IC-AUDIO AMP
IC-POWER AMP
IC-POWER AMP
IC-AUDIO AMP
IC-VOLTAGE COMP.
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-MULTI REG.
IC-MULTI REG.
IC-MULTI REG.
IC-DC/DC CONVERTER
SA
SA
SA
SA
SNA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
1203-004548
1203-004727
1203-004728
1203-004728
1203-004776
1203-004776
1203-004778
1203-004819
1203-004838
1205-002784
1205-003228
1205-003281
1205-003288
1205-003297
1404-001224
2007-000138
2007-000138
2007-000138
2007-000138
2007-000138
2007-000138
2007-000138
2007-000138
2007-000138
2007-000140
2007-000140
2007-000140
2007-000140
2007-000140
2007-000140
2007-000140
2007-000143
2007-000143
2007-000143
2007-000144
2007-000148
2007-000157
2007-000160
2007-000160
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
2007-000162
U602
U405
U508
U509
U600
U603
U401
U604
U400
U410
U503
UCP300
U700
U201
VR300
R108
R322
R328
R515
R516
R517
R535
R707
R726
R314
R502
R504
R520
R521
R529
R530
R318
R509
R510
R415
R413
R416
R505
R508
R330
R430
R431
R432
R531
R619
R631
R632
R704
R716
IC-DC/DC CONVERTER
IC-DC/DC CONVERTER
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-POWER SUPERVISOR
IC-POSI.FIXED REG.
IC-BATTERY
IC-SWITCH
IC-CODEC
IC-MODEM
IC-LCD CONTROLLER
IC-TRANSCEIVER
THERMISTOR-NTC
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2007-000165
2007-000169
2007-000169
2007-000170
2007-000170
2007-000170
2007-000170
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000171
2007-000173
2007-000173
2007-001156
2007-001156
2007-001285
R513
R503
R506
R300
R507
R512
R621
L205
L405
R200
R201
R203
R207
R304
R305
R307
R317
R324
R400
R414
R420
R421
R422
R433
R434
R435
R500
R501
R511
R514
R601
R602
R611
R612
R613
R614
R616
R617
R625
R627
R628
R711
R712
R729
R610
R615
R404
R623
R205
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2007-001285
2007-001290
2007-001319
2007-001319
2007-001319
2007-001319
2007-001319
2007-001319
2007-001319
2007-001339
2007-001339
2007-002970
2007-002970
2007-002970
2007-002970
2007-003010
2007-003010
2007-007009
2007-007009
2007-007014
2007-007014
2007-007014
2007-007014
2007-007014
2007-007014
2007-007092
2007-007092
2007-007135
2007-007306
2007-007306
2007-007314
2007-007316
2007-007317
2007-007334
2007-007334
2007-007468
2007-007741
2007-007741
2007-007741
2007-007766
2007-008046
2007-008046
2007-008052
2007-008055
2007-008055
2007-008055
2007-008419
2007-008483
2007-008483
R206
R327
R522
R523
R527
R528
R607
R701
R702
R334
R603
R533
R534
R536
R537
R539
R540
R110
R622
R308
R309
R310
R311
R312
R408
R608
R609
R313
R111
R112
R321
R403
R402
R418
R725
R406
R103
R424
R426
R329
R105
R106
R425
R427
R705
R717
R204
R718
R719
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2007-008483
2007-008483
2007-008483
2007-008516
2007-008516
2007-008516
2007-008516
2007-008516
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008542
2007-008579
2007-008579
2007-008588
2007-008588
2007-008588
2007-008588
2007-008588
2007-008806
2007-008806
2007-008806
2007-008806
2007-009111
2007-009157
2007-009170
2007-009170
2007-009170
2007-009170
2007-009171
2007-009420
2007-009801
2007-009810
2007-009866
2007-009866
2203-000233
2203-000233
R720
R721
R722
R315
R316
R320
R524
R723
R306
R331
R332
R405
R411
R412
R437
R538
R618
R629
R634
R637
R732
R733
R734
R735
R101
R102
R107
R302
R303
R706
R710
R104
R109
R325
R410
R100
R626
R333
R519
R605
R727
R409
R202
R604
R620
R401
R525
C211
C248
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-000233
2203-000233
2203-000233
2203-000233
2203-000233
2203-000254
2203-000254
2203-000254
2203-000254
2203-000254
2203-000254
2203-000254
2203-000278
2203-000278
2203-000278
2203-000278
2203-000278
2203-000330
2203-000330
2203-000386
2203-000438
2203-000438
2203-000438
2203-000438
2203-000489
2203-000725
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000812
2203-000854
C258
C343
C426
C429
C431
C124
C300
C301
C302
C308
C312
C323
C254
C334
C339
C622
C623
C416
C436
C548
C202
C232
C526
C527
C346
C738
C116
C117
C125
C126
C127
C137
C342
C411
C427
C461
C511
C520
C618
C701
C702
C703
C704
C723
C727
C729
C733
C734
C333
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-000854
2203-000854
2203-000854
2203-000854
2203-000854
2203-000995
2203-000995
2203-001033
2203-001153
2203-002487
2203-002487
2203-002677
2203-003054
2203-003054
2203-003054
2203-005052
2203-005057
2203-005057
2203-005234
2203-005234
2203-005281
2203-005450
2203-005450
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005571
2203-005571
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
C337
C538
C539
C541
C555
C106
C345
C711
C118
C509
C515
C128
C501
C502
C547
L112
L108
L110
C122
L100
C204
L105
L107
C105
C119
C207
C208
C215
C344
C347
C405
C504
C506
C524
C525
C537
C540
C543
C550
C553
C558
C428
C430
C107
C110
C111
C115
C136
C221
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005682
2203-005719
2203-005719
2203-005719
2203-005719
2203-005719
2203-005719
2203-005719
2203-005719
2203-005719
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005725
2203-005729
2203-005732
C238
C316
C330
C707
C708
C709
C710
C712
C739
C740
C741
C742
C744
C745
C747
C749
C750
C338
C340
C518
C529
C542
C556
C614
C615
C743
C108
C112
C132
C133
C212
C218
C222
C226
C233
C236
C237
C240
C241
C242
C244
C245
C256
C259
C260
C263
C265
C549
C200
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-005732
2203-005734
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005736
2203-005806
2203-005806
2203-005806
2203-005806
2203-006047
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006048
2203-006091
2203-006091
2203-006121
2203-006137
C201
C114
C131
C209
C210
C216
C223
C235
C246
C255
C257
C266
C435
C440
C123
C130
C228
C320
C349
C303
C304
C309
C313
C314
C321
C322
C341
C404
C407
C408
C409
C410
C604
C605
C606
C617
C630
C718
C720
C722
C724
C726
C728
C735
R731
C512
C514
C620
C544
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SNA
SNA
SNA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-9
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-006137
2203-006194
2203-006194
2203-006194
2203-006194
2203-006208
2203-006208
2203-006257
2203-006257
2203-006257
2203-006257
2203-006260
2203-006305
2203-006324
2203-006324
2203-006324
2203-006348
2203-006348
2203-006348
2203-006399
2203-006399
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
C551
C129
C135
C319
C331
C453
C627
C517
C519
C530
C532
C621
C521
C438
C454
C628
C412
C414
C437
C418
C434
C134
C205
C206
C217
C219
C220
C229
C230
C231
C239
C243
C247
C250
C252
C253
C261
C264
C328
C329
C332
C415
C447
C600
C601
C602
C603
C607
C608
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-10
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006423
2203-006466
2203-006466
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
C609
C610
C611
C612
C613
C616
C624
C635
C716
C748
C507
C510
C214
C305
C310
C311
C325
C326
C413
C441
C442
C443
C444
C445
C446
C448
C449
C450
C451
C452
C455
C456
C457
C458
C500
C508
C516
C533
C534
C535
C552
C554
C557
C559
C560
C625
C626
C629
C631
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-11
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006681
2203-006681
2203-006681
2203-006681
2203-006681
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006824
2203-006825
2203-006825
2203-006825
2203-006825
2203-006825
2203-006838
2203-006838
2203-006838
2203-006838
2203-006839
2203-006839
2203-006841
2203-006841
2203-006841
2203-006841
2203-006841
2203-006841
2203-006841
2203-006872
2203-006872
2203-006872
2203-006872
2203-006872
C632
C633
C637
C638
C705
C706
C713
C714
C715
C737
C746
C317
C318
C327
C348
C350
C249
C251
C307
C400
C401
C403
C417
C420
C422
C423
C224
C315
C545
C546
C634
C324
C503
C505
C636
C528
C531
C439
C513
C717
C719
C721
C725
C751
C225
C234
C306
C419
C421
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-12
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2203-006872
2203-006872
2203-006872
2203-006872
2203-006872
2203-006872
2203-006885
2203-006979
2203-006979
2404-001268
2404-001268
2404-001339
2404-001339
2404-001339
2404-001381
2404-001381
2404-001381
2404-001381
2404-001381
2404-001381
2404-001411
2404-001506
2703-001231
2703-001737
2703-001747
2703-001751
2703-002176
2703-002176
2703-002199
2703-002199
2703-002199
2703-002200
2703-002201
2703-002201
2703-002203
2703-002203
2703-002208
2703-002208
2703-002281
2703-002313
2703-002314
2703-002314
2703-002368
2703-002597
2703-002619
2703-002917
2703-003258
2703-003258
2703-003258
C424
C425
C432
C433
C536
C730
C619
C227
C262
TA400
TA401
C402
C406
TA700
TA101
TA402
TA403
TA500
TA600
TA601
TA701
TA100
L603
L202
L109
C203
C100
C101
C102
L508
L509
C103
C109
C113
L101
L104
L111
L207
L106
L200
L102
L103
L116
L206
L403
L204
L400
L401
L402
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-13
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
2703-003260
2703-003260
2801-004339
2801-004573
2809-001280
2901-001353
2901-001422
2901-001422
2901-001422
2901-001453
2901-001453
2904-001601
2904-001604
2904-001628
2904-001702
2904-001789
2910-000024
3301-001208
3301-001208
3301-001438
3301-001438
3301-001438
3301-001438
3301-001729
3301-001729
3301-001729
3301-001729
3301-001756
3301-001756
3301-001778
3301-001778
3408-001117
3705-001358
3705-001448
3708-002015
3709-001465
3710-002467
3710-002523
3711-005728
3711-006028
3711-006256
4202-001395
4302-001180
4709-001399
4709-001546
GH13-00061A
GH70-02640A
GH70-02640A
GH70-02640A
L404
L604
OSC400
OSC600
TCX100
F701
F703
F704
F705
F700
F702
F102
F101
F100
F200
F103
DUF100
L501
L503
L500
L502
L504
L602
L505
L506
L507
R428
L510
L511
L600
L601
HOLDSW700
RFS100
RFS101
SLC700
SIM700
MOT700
IFC600
HEA700
HDC700
BTC700
ANT200
BAT400
CPL100
U200
UCP600
SC200
SC201
SC202
INDUCTOR-SMD
INDUCTOR-SMD
CRYSTAL-SMD
CRYSTAL-SMD
OSCILLATOR-VCTCXO
FILTER-EMI/ESD
FILTER-EMI SMD
FILTER-EMI SMD
FILTER-EMI SMD
FILTER-EMI SMD
FILTER-EMI SMD
FILTER-SAW
FILTER-SAW
FILTER-SAW
FILTER-SAW
FILTER-SAW
DUPLEXER-SAW
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
CORE-FERRITE BEAD
CORE-FERRITE BEAD
SWITCH-SLIDE
CONNECTOR-COAXIAL
CONNECTOR-COAXIAL
CONNECTOR-FPC/FFC/PIC
CONNECTOR-CARD EDGE
SOCKET-BOARD TO BOARD
SOCKET-INTERFACE
HEADER-BOARD TO BOARD
HEADER-BOARD TO BOARD
HEADER-BATTERY
ANTENNA-CHIP
BATTERY-LI(2ND)
COUPLER-DIRECTION
BLUETOOTH MODULE
IC ASIC-SGHF490
ICT SHIELD-CAN CLIP
ICT SHIELD-CAN CLIP
ICT SHIELD-CAN CLIP
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-14
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
SEC Code
Design LOC
Description
STATUS
GH70-02640A
GH70-02640A
GH70-02640A
SC203
SC204
SC205
ICT SHIELD-CAN CLIP
ICT SHIELD-CAN CLIP
ICT SHIELD-CAN CLIP
SA
SA
SA
Please consult the GSPN website (Samsung Portal) for the most recent version of the product's
part list.
6-15
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
6-16
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
7. Block Diagrams
7-1. Functional Block Diagram
RX_Q_P
RX_Q_M
RX_I_P
RX_I_M
EGSM
RX SAW
VRAMP
DCS
ANT_SEL0
TX Mo d ule
( SKY77519)
ANT_SEL1
RX SAW
PCS
TRANSCIVER
( RTR6285)
RX SAW
DCS / PCS
GSM
TCXO
WCDMA BAND 1
19. 2MHz
COUPLER
WCDMA PAM
( AWT6279RM20P8)
DUPLEXER
PWR_DETECT
RX SAW
TX SAW
7-1
TX_Q_P
TX_Q_M
TX_I_P
TX_I_M
Block Diagrams
7-2. Baseband Block Diagram
VBATT_CTRL_4.2V
LDO
LDO
TOUCH_2.8V
LCD _2.6V
TOUCH_OUT
T O U CH _ I 2 C
Touch Screen
3.2" WQVGA LCD
S 20
Connector
L CD _ R S T
( 240*432, 16bit CPU type )
R ES ET _N
AM UX _OUT
LCD_D(0:17)
LCD
Serializer
EA RMIC
S 20_EA R
EAR _S W
S SBI
USB_DP/DM
LCD
DE-serializer
SLEEP_XTAL_IN
32.768KH z
LCD_D(0:15)
M ic r o U S B
EBI2
TCXO_EN
TCXO_OUT
M/M Chip ( MV8722 )
24MHz
X-Tal
To USB SWITCH
USB _DP/DN
LDO
LDO
C AM_D(0:7) CLK, SYNC
M CA M _ 1 . 8 V
IO/A_2.8V
AF _3.3V
ISP_2.8V
LDO
V CA M _ 1 . 8 V
IO/A_2.8V
Boost
Converter
LDO
MOT_3.3V
To
S20/Micro USB
CAM_I2C
VGA CAM
F rom M V8722
US B_DP/DN
USB _OE/D AT/SEO
Switch
U SB_DP/DM
USB
SWITCH
CA M_I2C
CAM_D(0:7)
CLK, SYNC
VBATT_4.2V
BOOT_SW
VC OIN
MODEM
(MSM6260)
5M AF CAM
I2C
PS_HOLD
PS_H O LD
19.2M
T CX O
T-Flash
SD_D(0:3)
PM6658
SIM _IO
USIM_C LK/R ST
USIM_IO
USIM
Flash LED
FLASH_EN
Haptic
Driver
LRA MOTOR
MOTOR _PWM
I2S
Switch
S20 EAR L/R
3.5 EAR L/R
R C V_L/ R
Amp
CODEC_OUT (L)
Amp
CODEC_OUT(R)
Switch
EA R L / R
CODEC_I2C
CODEC
C O DE C_ RS T
CHG_EN_N
Charging IC
HPH_L/R
A1(0:12)
Toshiba Memory
S 2 0 3. 5_SEL
RADIO_OUT_R /L
BT
MODULE
BT_U ART
BT_PCM
7-2
EB I1
SDRAM (1G)
EBI2
NAND Flash (2G)
8. PCB Diagrams
1. Main top
8-1
PCB Diagrams
2. Main bottom
8-2
9. Flow Chart of Troubleshooting
9-1. Power On
' Power On ' does not work
Yes
No
Check the Battery Voltage
Change the Battery
is more than 3.4V
Yes
No
U401 pin F10(PS_HOLD)
= 2.6V?
Check the U401 related to PS_HOLD
Yes
No
Check the Clock at
OSC400=32.768KHz
Resolder OSC400
Yes
No
Check the U401
L400(VREG_MSMC)=1.2V?
Yes
No
C424(VREG_MSME)=1.8V?
C423(VREG_MSMP)=2.6V?
C422(VREG_MSMA)=2.6V?
C418(VREG_TCXO)=2.8V?
Check the U401
Yes
No
Check for the clock at C435
Check the clock generation circuit
(related to TCX100)
= 19.2MHz
Yes
Check the initial operation
Yes
END
9-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
D4
OPT_1
H8
OPT_2
CLK19.2M_TCXO
CLK19.2M_PM
C435
R410
TP_RF_TCXO
USB_DAT
USB_DM_MODEM
USB_DP_MODEM
G4
J1
J2
H2
F4
F2
H4
H1
R411
R412
USB_OE_N
USB_SEO
USB_VBUS_5V
USB_DAT
USB_D_M
USB_D_P
USB_ID
USB_OE_N
USB_OVP_G
USB_SE0
USB_VBUS
E5
E6
E7
F5
F6
F7
G5
G6
G7
R416
C438
TCXO_EN_1
TCXO_EN_2
TCXO_IN
TCXO_OUT_1
TCXO_OUT_2
TCXO_OUT_RF
VBATT_4.2V
VREG_MSMP_2.6V
C416
OSC400
L11
XTAL_IN
K11
XTAL_OUT
F8
SBCK
G8
SBDT|SSBI
E8
SBST
VCOIN
BAT_FET_N
CHG_CTL_N
VCHG
HSET_BIAS
KPD_PWR_N
MSM_INT_N
PON_RESET_N
PS_HOLD
SLEEP_CLK
J10
E2
C2
C1
K1
L4
C10
G10
F10
K9
R408
R409
C436
SSBI2_DATA
TP401
TP402
TP403
D400
PM_INT
ON_SW
PM_INT_N
RESET_N
2
3
SLEEP_XTAL_IN
GND
GND
GND
GND
GND
GND
GND
GND
GND
DNC
NC
NC
D8
E4
E11
H10
B10
F11
TCXO_EN
U401
D1 R437
ISNS_M
D2
ISNS_P
1
B5
SPKR_IN_M
B6
SPKR_IN_P
A5
SPKR_OUT_M
A6
SPKR_OUT_P
2
R406
A1
VREG_TCXO
G2
VREG_USB
B11
VREG_WLAN
C415 C11
REF_BYP
E10
REF_GND
D10
REF_ISET
D11
1
2
TP400
R405
R418
9-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
1
PS_HOLD
BOOT_SW
Flow Chart of Troubleshooting
VREG_MSMP_2.6V
VREG_USIM_3.0V
VREG_TCXO_2.85V
VREG_S2_2.1V
VREG_MSMA_2.6V
VREG_MSME_1.8V
VREG_S3_2.7V
VREG_BT_2.85V
R400
VREG_MSMC_1.2V
C422
C423
C424
C425
C434
C430
C431
C418
C417 C426 C427 C428 C429
9-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C432
C433
Flow Chart of Troubleshooting
R108
C123
TRK_LO_ADJ
CLK19.2M_RTR
C124
2
1
VREG_TCXO_2.85V
VCON GND
TCX100
VCC
OUT
4
3
C129
CLK19.2M_TCXO
C136
TA 1 0 0
C1 1 1
C114
R107
R104
R1 0 5
F1 0 0
F1 0 1
R106
C4 1 5
R4 0 6
R10 0
9-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C1 0 6
C1 0 5
C422
C1 1 0
C1 1 5
R1 0 3
TP4 0 3TP_AMUX_ OUT
TCX100
C1 2 4
C107
R1 0 8
C108
L1 0 1
C112
L102
PAM1 0 0
C4 3 5
R4 0 5
R4 1 0
R4 0 9
C423
C109
L1 0 4
C436
L1 0 5
L400
C113
L1 0 7
C417
L1 0 8
C404
L1 1 0
C410
C429
L4 0 2
C4 0 3
OSC4 0 0
L401
F1 0 2
C130
C135
U4 0 1
C134
R101
Flow Chart of Troubleshooting
9-2. Initial
Initial Failure
Yes
No
pin G13, G12 of UCP300 ="H"?
Check the circuit connected to reset
Yes
No
IS [TP300,TP303,TP305,
TP306,TP307,TP308,TP
309,,TP301]
OK?
Check the circuit related to UME300
Yes
Check the circuit around LCD & HDC700
(Short or not solder)
Yes
END
9-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G13
G12
W5
RESET_N
RESET_OUT_N
R327
AA1
G1
M4
SDRAM_CLK
SDRAM_RAS
SDRAM_CKE
A15
B15
SLEEP_XTAL_IN
TP_SLEEP_CLK_OUT
V2
AE6
OE2_N
V4
U5
W14
AB14
SDRAM_CS0
NAND_CE
MV_CS_N
V5
K8
SDRAM_CAS
R329
TRK_LO_ADJ
H13
E13
E11
TP_TX_AGC_ADJ
RF_ON
RESIN_N
RESOUT_N
RESOUT_N_EBI1
ROM1_CLK
ROM1_ADV_N
SDRAM1_CLK_EN
SLEEP_XTAL_IN
SLEEP_XTAL_OUT
OE1_N
OE2_N
XMEM1_CS_N0
XMEM1_CS_N2
XMEM2_CS_N0
XMEM2_CS_N1
XMEM1_HWAIT_N
XMEM1_LWAIT_N
TRK_LO_ADJ
TX_AGC_ADJ
TX_ON
TP3
TP308
C621
TP6 0 4
R623
R616
TP6 0 0
TP6 0 1
R617
TP6 0 2
C602
C603
C324
C3 3 0
C3 3 2
C3 3 1
D602
TP3 0 5
UME3 0 0
C3 2 8
UCP600
R614
C630
TP307
A600
MV_CS_N
OE600
MV_INT
U6 0 1
TP603
WE600
R630
C624
C541
R7 0 5
C7 1 2
U5 0 8
C7 0 9
C7 1 0
HD C7 0 0
C7 0 8
TA4 0 3
C7 0 7
R3 3 2
C545
R5 2 9
C550
R7 3 6
C554
R5 2 7
3
C5 4 7
C5 4 8
R520
C55
C555
C543
R5 2 2
C5 3 6
C319
C7 3 5
C7 3 3
D7 0 0
C7 3 4
TA701
C320
C5 3 8
C329
TP3 0 3
C316
U410
9-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
35
33
C607
00
C620
R622
01
00
09
TP306
1
0
1
0
C349
D1(0)
D1(1)
D1(2)
D1(3)
D1(4)
D1(5)
D1(6)
D1(7)
D1(8)
D1(9)
D1(10)
D1(11)
D1(12)
D1(13)
D1(14)
D1(15)
D1(16)
D1(17)
D1(18)
D1(19)
D1(20)
D1(21)
D1(22)
D1(23)
D1(24)
D1(25)
D1(26)
D1(27)
D1(28)
D1(29)
D1(30)
D1(31)
U4
T4
T5
V5
U5
T6
V6
U7
T9
T10
V10
T11
U11
V11
T12
U12
P3
R3
P4
R4
P5
R5
P6
R6
P9
P10
R10
P11
R11
P12
R12
R13
U8
T8
V7
U9
SDRAM_DQM0
SDRAM_DQM1
SDRAM_DQM2
SDRAM_DQM3
D2(0:7)
D2(0)
D2(1)
D2(2)
D2(3)
D2(4)
D2(5)
D2(6)
D2(7)
D2(8)
D2(9)
D2(10)
D2(11)
D2(12)
D2(13)
D2(14)
D2(15)
D2(8:15)
SDRAM_RAS
OE2_N
SDRAM_WE
WE2_N
RESET_OUT_N
E3
E2
D12
C12
D11
C11
D10
C10
E4
D9
C9
TP303
D1(0:31)
SDRAM_BA0
SDRAM_BA1
NAND_ALE
SDRAM_CKE
NAND_CLE
SDRAM_CLK
NAND_READY
SDRAM_CAS
NAND_CE
SDRAM_CS0
TP305
TP306
TP307
TP308
TP309
TP310
M11
M13
L10
L12
J9
H12
H10
G12
M12
L9
L11
K9
H13
H11
H9
G11
C4
D4
M3
D8
M4
C8
M2
E6
M9
D7
E5
D5
M10
D6
K6
L6
K1
C
N
V
C
D
Q
C
V
C
V
1
V
V
D
Q
C
V
C
C
D
C
V
V
D
D
1
V
C
D
C
V
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
C
D
C
V
C3
TP300D3
C
D
C
V
A1(0)
A1(1)
A1(2)
A1(3)
A1(4)
A1(5)
A1(6)
A1(7)
A1(8)
A1(9)
A1(10)
A1(11)
A1(12)
C
D
C
V
A1(0:12)
D
C
V
C
C
Flow Chart of Troubleshooting
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
DQ16
DQ17
DQ18
DQ19
DQ20
DQ21
DQ22
DQ23
DQ24
DQ25
DQ26
DQ27
DQ28
DQ29
DQ30
DQ31
DQM0
DQM1
DQM2
DQM3
UME300
I|O1
I|O2
I|O3
I|O4
I|O5
I|O6
I|O7
I|O8
I|O9
I|O10
I|O11
I|O12
I|O13
I|O14
I|O15
I|O16
BA0
BA1
ALE
CKE
CLE
CLK
RY|BY
CAS
CE
CS
CS
RAS
RE
WED
WEN
WP
9-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
C13
C14
D1
D14
E1
E7
E8
E9
E10
E11
E12
E13
F2
F3
F4
F5
F6
F8
F9
F10
F11
F12
F13
G3
G4
G5
G6
G7
G8
G9
G10
H2
H3
H4
H5
H6
J2
J3
J4
J5
J6
J10
J11
J12
J13
K1
K2
K3
K4
K5
K10
K11
K13
K14
L1
L2
L3
L4
L5
L14
M5
M6
N2
N3
N4
N5
N6
N9
N10
N11
N12
N13
P7
P8
R2
R7
R9
T2
T3
T7
T13
U1
U3
Flow Chart of Troubleshooting
9-3. Charging Part
Abnormal charging part
Yes
No
C619=5V?
Resolder IFC600
Yes
No
U400 pin5 = "H"?
Replace U400
Yes
Check the Battery & TA
Yes
END
VBATT_4.2V
VREG_MSMP_2.6V
U400
1 USBIN
USB_VBUS_5V
R401
2 IUSB
BAT 9
3 ITERM
IDC 8
4 PWR
CHG_INDICATE
C412
R403
R404
DCIN 10
VEXT_5V
BATDET 7
5 CHRG
GND
11
VF
EN 6
CHG_EN_N
R402
C413
9-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C414
Flow Chart of Troubleshooting
VEXT_5V
VBATT_4.2V
IFC600
1
2
3
4
5
6
7
8
9
10
11
12
L600
L601
R607
R608
R609
13
14
15
16
17
18
19
20
21
22
23
24
25
26
R610
TA601
R521
L510
C544
L511
C551
C614
R528
C6 1 5
R532
D600
R607
R608
D601
R609
TA601
SLC700
R404
R3 1 0
R430
C617
C619
U301
9-9
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
R7 2 5
C6 1 8
R402
C4 5 7
U4 0 0
C414
C413
R605
R6 0 3
C412
C5 4 9
C703
L600
R7 1 6
C70 2
L5 0 4
ZD701 ZD702
R523
C556
I FC6 0 0
R732
C542
L601
C7 3 8
C704
R733
L6 0 2
M OT7 0 0
ZD700
R734
Z D 7 0 3 C7 0 1
R735
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
Flow Chart of Troubleshooting
9-4. Sim Part
Phone can't access SIM Card
Yes
No
C740="H"?
Check the SIM POWER
Yes
No
After Power ON,
Check the 32.768 kHz OSC400
Check USIM_CLK Signal on
pin15 of SIM700 in a few
second
Yes
No
Replace PBA
After SIM card insert,
pin 13 of SIM700 =
"H(USIM_RST)"?
Yes
Check the SIM Card
Yes
END
9-10
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VREG_MMC_2.8V
R729
VREG_MSMP_2.6V
VREG_USIM_3.0V
D701
1
2
CH4
CH2
CH3
5
4
R723
R722
R721
R720
R719
R718
VN
6
SD_CLK
SD_D(0)
SD_D(1)
USIM_RST
R724
USIM_CLK
USIM_IO
D702
R728
C750
3
CH5
VN
CH2
C410
C429
CH4
CH3
L4 0 2
03
OSC4 0 0
L401
CH1
C404
S I M7 0 0
C436
U4 0 1
C4 3 5
R4 1 0
R4 0 5
R4 0 9
L400
R4 3 7
R4 1 3
C4 1 5
R4 0 6
R4 3
C4 3
C4 3
C407
R7 1 7
R7 1 9
R7 1 8
C7 4 0
C750
C7 4 9
R723
C4 2 1
C4 2 5
R7 2 4
R4 3 4
C7 4 8
R312
C40 8
C417
C418
C422
C746
5
4
9-11
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C409
C4 0 5
C423
R729
6
TP4 0 3TP_AMUX_ OUT
C749
C739
C748
C746
C747
2
C745
C744
C743
1
C742
10
11
12
13
14
15
16
17
18
19
20
21
22
23
CH5
SD_DETECT
SD_D(2)
SD_D(3)
SD_CMD
C741
1
2
3
4
5
6
7
8
9
C740
SW-B
SW-A
1
2
3
4
5
6
7
8
C1
C5
C2
C6
C3
C7
NC
NC
NC
NC
NC
NC
NC
R717
3
SIM700
CH1
Flow Chart of Troubleshooting
9-5. Microphone Part
Microphone does not work
Yes
No
Resolder the microphone FPCB
check the microphone FPCB
Yes
No
Resolder or change U508
C554 is 2.0V
Yes
Is microphone ok?
No
Change the microphone
Yes
END
9-12
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
PHONE_MICBIAS_2.0V
VBATT_4.2V
U508
1 EN
MICBIAS_EN
BYP
2 GND
NC 5
VOUT 4
GND
3 VIN
6
7
R531
C554
C553
35
33
R520
C55 3
C554
U5 0 8
TA701
D7 0 0
734
413
C437
BTC700
C545
U410
C552
C5 5 2
R5 3 1
TA402
9-13
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-6. Speaker Part(Melody)
Speaker does not work
No
Is the terminal of speaker
OK?
Check the Speaker Wire
Yes
No
Check the AMP_N/P ok?
Resolder the Speaker wire
Yes
No
Check the Earjack FPCB
ok?
Change or Resolder Earjack FPCB
Yes
No
Check the output circuit
of U501
Change or Resolder U501
Yes
No
Is the CODECOUT_M and
CODECOUT_P ok?
Check the C512,C514,R505,R508
= 'H'
Yes
No
C600,C601,C602,C603,
is 'H' ?
Change or Resolder U404
Yes
No
Is Speaker OK ?
Change the Speaker
Yes
END
9-14
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VBATT_4.2V
U501
C512
R505
C514
R508
CODECOUT_M
CODECOUT_P
12
NC NC
C1
B1
INVDD
A1 IN+
B2
VDD
C2 _SHUT VO- A3
AMP_EN
VO+ C3
G G2
A2 B3
C513
TA500
L501
AMP_N
AMP_P
L503
C526
VREG_MV_1.8V
VREG_MV_2.6V
C600
C636
C602
C603
LCD_D(0:17)
LD0
LD1
H13
H14
H15
C527
LCD_D(0)
LCD_D(1)
LCD_D(2)
9-15
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C601
Flow Chart of Troubleshooting
VBATT_4.2V
VREG_CODEC_1.8V
VREG_CODEC_2.8V
U404
1
CODEC_PWR_EN
2
CE1 VOUT1 8
VDD 7
3
CE2 VOUT2 6
4
NC 5
NC
G ND
GND
9
C449
C448
C526
L501
L506
C512
R508
C514
C508
R306
C5 1 3
C5 0 0
R316
C5 1 6
R320
R505
TA500
U500
C5 1 0
R501
C502
R500
C501
C5 1 7
U404
C507
ZD705
H O LD S W 7 0 0
R5 1 6
L503
C527
U5 0 1
C5 3 5
U506
C450
C621
TP6 0 4
R623
R616
TP_ D OUT
TP6 0 1
UCP600
TP6 0 2
C3 2 8
C602
TP_LRCLK
C324
R6 1
C3 3 2
C3 3 0
C3 3 1
TP_MCLK
R619
C6 3 6
TP_ BCLK
C603
TP_ D I N
R614
R6 2 0
TP6 0 0
R617
9-16
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-7. Receiver Part
Receiver does not work
Yes
No
Check the Speaker wire
Does Speaker work well?
Yes
No
pin4,pin9 of U506 and
pin4, pin9 of U505 is 'H' ?
Change the U505,U506
Yes
R516 , R517 is 'H' ?
No
Change or resolder R516,R517
Yes
No
Is Receiver OK ?
Change the Speaker
Yes
END
9-17
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VBATT_4.2V
L507
RCV_SPK_SEL
1 IN 9
1S2
GND 8
2
1S1
2S1 7
3
VCC
2S2 6
2 IN
AMP_N
AMP_P
1
4
C534
SPK_N
SPK_P
D2
RCV_N_OUT
5
R 51 7
D1 10
U505
RCV_SPK_SEL
RCV_P_OUT
VBATT_4.2V
L506
RCV_SPK_SEL
1S2
GND 8
2
1S1
2S1 7
VCC
2S2 6
4
2IN
3
C535
1IN 9
1
D2
RCV_N
RCV_P
R539
RCV_N_OUT
RCV_P_OUT
R540
5
R516
D1 10
U506
RCV_SPK_SEL
9-18
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
R540
R5 1 6
L5 0 7
C5 3 4
R5 3 9
R517
U506
C5 3 5
U505
C527
C526
L506
L503
L501
9-19
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-8. LCD part
LCD does not work
Yes
No
Is the LCD FPCB
connected in HDC700?
Put the LCD FPCB on HDC700
Yes
No
R704 , C714=3.0V?
Replace U701
Yes
No
Is Slide FPCB OK ?
Replace the Slide FPCB
Yes
Replace the LCD Module
Not OK
Check the UCP600 ,U410
END
9-20
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VREG_LCD_3.0V
V_DC
VREG_LCD_3.0V
VREG_MSMP_2.6V
39
37
35
33
31
29
27
25
23
21
19
17
15
13
11
9
7
5
3
1
BL_LDO_EN
LCD_RST
EMI_FLM
KEY_LED_EN3
KEY_LED_EN2
KEY_LED_EN1
MLCD_BL_EN
MAINMIC_N
MAINMIC_P
39
37
35
33
31
29
27
25
23
21
19
17
15
13
11
9
7
5
3
1
LCD(0)
LCD(1)
LCD(2)
LCD(3)
LCD(4)
LCD(5)
LCD(6)
LCD(7)
LCD(8)
LCD(9)
LCD(10)
LCD(11)
LCD(12)
LCD(13)
LCD(14)
LCD(15)
EMI_RS
EMI_L_WR
40 40
38 38
36 36
34 34
32 32
30 30
28 28
26 26
24 24
22 22
20 20
18 18
16 16
14 14
12 12
10 10
8 8
6 6
4 4
2 2
R704
EMI_MAIN_LCD_CS
C715
C714
C 713
C 712
C711
C 710
C 708
C 707
R 705
C 709
R704
C624
F7 0 1
C541
F7 0 2
HD C7 0 0
C7 0 9
C7 1 0
R7 0 5
C7 1 2
F7 0 0
C7 0 7
TA4 0 3
C7 1
C7 0
U7 0 1
C7 0
C7 1 5
C711
C7 0 8
R3 3 2
R7 3 6
C713
TA402
R5 2 9
R5 2 7
C550
C545
C5 4 7
C5 4 8
R5 2 2
C555
C543
U410
R736
HDC700
9-21
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-9. Camera part ( 5 Mega )
"5 Mega Camera" function does not work
Yes
Not OK
Is the Camera
connected in HEA700 ?
Put the camera module on HEA700
OK
HEA700
pin20, pin23≒2.8V
and pin11≒1.8V ?
No
Replace U402
Yes
No
HEA700
pin17≒2.8V ?
Replace U403
Yes
No
HEA700
pin7,pin29≒1.5V ?
Replace U407
Yes
No
HEA700
pin24≒2.8V ?
Replace U408
No
Is R711, R420,R421,R422
R428 and L405 placed in
board?
Replace R711, R420,R421,R422 R428
and L405
Yes
9-22
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
No
Is F703, F704 and F705
placed in board ?
Replace F703, F704 and F705
Yes
Replace the 5mega camera module
Not OK
Check the UCP600
END
9-23
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VDD_VCM_3.3V
CAM_ISP_CORE_1.5V
5M_VT_CORE_1.8V
CAM_FVDD_2.8V
CAM_SVDD_2.8V
CAM_ISP_1.5V
CAM_DVDD_2.8V
5M_AVDD_2.8V
HEA700
C731
R712
C 726
C 725
C723
C 724
C 721
C 722
C 719
C 720
C 718
R 731
C 751
CAMD(4)
C 732
R711
31
32 N C
NC
CAMD(7)
5M_RESET
CAMD(0)
CAMD(2)
C717
CAMD(3)
CAMD(5)
CAM_MCLK
CAM_PCLK
CAMI2C_SCL
CAMI2C_SDA
C 730
CAMVSYNC
CAMD(1)
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
C728
VCAM_EN
CAMHSYNC
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
C 729
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29 29
C 727
1
3
5
7
9
11
13
15
17
19
21
23
25
27
5M_VT_CORE_1.8V
CAM_SVDD_2.8V CAM_DVDD_2.8V
VBATT_4.2V
2
CE1 VOUT1 8
VDD 7
6
CE2 VOUT2
4
NC 5
NC
GND
3
9
C441
C442
C443
9-24
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
R421
1
GND
CAM_PWR_EN1
R420
U402
CAMD(6)
VT_RESET
Flow Chart of Troubleshooting
VBATT_4.2V
VDD_VCM_3.3V
5M_AVDD_2.8V
1
CAM_PWR_EN3
2
R422
U403
CE1 VOUT1 8
VDD 7
3
6
CE2 VOUT2
4
NC 5
NC
GND
CAM_PWR_EN1
GND
9
C444
C446
C445
CAM_ISP_CORE_1.5V
CAM_ISP_1.5V
R428
C461
VBATT_4.2V
U407
L 405
L404
1
LX
IN 6
2 GND GND 5
3 OUT
4
_SHDN
CAM_PWR_EN2
C453
R432
C454
9-25
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VBATT_4.2V
CAM_FVDD_2.8V
U408
3 VIN
VOUT 4
2 GND
1 STBY
CAM_PWR_EN2
NC 5
GND
6
R431
C455
C456
LED400
C456
F7 0 5
ZD401
U408
R4 3 1
C6 3 8
HEA700
C455
F703
C637
U605
R636
F704
C441
C443
C445
C722
C725
C723
C720
C718
C721
C719
C751
R535
R307
R711
R731
R533
R634
C560
SC202
C243
C2 6 4
R2 0 7
R205
C255
C250
9-26
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
C223
C231
C220
C237
C2 2 7
C245
C2 3 2
C2 2 8
C2 3 5
C2 2 9
C2 3 4
C249
R3 0 2
R7 1 0
R3 0 3
R7 0 6
U402
C444
C7 1 6
L4 0 4
C4 5 3
U4 0 7
C442
R420
C724
U7 0 2
R428
L405
C446
R7 0 7
C461
R421
U4 0 3
R422
Flow Chart of Troubleshooting
9-10. Camera part ( QCIF )
"QCIF Camera" function does not work
Yes
No
Is the Camera
connected in HEA700 ?
Put the camera module on HEA700
Yes
No
HEA700
pin20, pin23≒2.8V
and pin11≒1.8V ?
Replace U402
Yes
No
HEA700
pin17≒2.8V
Replace U403
Yes
No
Is R712, R421 and R422
placed in board ?
Replace R712, R421 and R422
Yes
No
Is F703, F704 and F705
placed in board ?
Replace F703, F704 and F705
Yes
Replace the QCIF camera module
Not OK
Check the UCP300
END
9-27
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
VDD_VCM_3.3V
CAM_ISP_CORE_1.5V
5M_VT_CORE_1.8V
CAM_FVDD_2.8V
CAM_SVDD_2.8V
CAM_ISP_1.5V
CAM_DVDD_2.8V
5M_AVDD_2.8V
HEA700
C 731
R712
C 726
C 725
C723
C 724
C 721
C 722
C 719
C 720
C 718
R 731
C 751
CAMD(4)
C 732
R711
31
32 N C
NC
CAMD(7)
5M_RESET
CAMD(0)
CAMD(2)
C 717
CAMD(3)
CAMD(5)
CAM_MCLK
CAM_PCLK
CAMI2C_SCL
CAMI2C_SDA
C 730
CAMVSYNC
CAMD(1)
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
C728
VCAM_EN
CAMHSYNC
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
C 729
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29 29
C 727
1
3
5
7
9
11
13
15
17
19
21
23
25
27
5M_VT_CORE_1.8V
CAM_SVDD_2.8V CAM_DVDD_2.8V
VBATT_4.2V
2
CE1 VOUT1 8
VDD 7
6
CE2 VOUT2
4
NC 5
NC
GND
3
9
C441
C442
C443
9-28
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
R421
1
GND
CAM_PWR_EN1
R420
U402
CAMD(6)
VT_RESET
Flow Chart of Troubleshooting
VBATT_4.2V
VDD_VCM_3.3V
5M_AVDD_2.8V
1
CAM_PWR_EN3
R422
U403
CE1 VOUT1 8
2
VDD 7
3
6
CE2 VOUT2
4
NC 5
NC
GND
CAM_PWR_EN1
GND
9
C444
C732
R611
C727
R7 1 2
R304
C7 3 0
C726
C7 1 7
R317
C7 2 9
C731
C7 2 8
R612
C446
C445
C456
F7 0 5
ZD401
U408
R4 3 1
C6 3 8
HEA700
C455
F703
C637
R636
F704
U605
R421
C444
C443
C445
U7 0 2
C441
R420
R7 0 7
C442
C446
U4 0 3
R422
C724
C725
C722
C723
C720
C718
C721
C719
C751
R535
R307
R711
R731
R533
R634
C560
U402
9-29
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-11. Touch
part
Touch module does not work
Yes
Is the TSP FPCB
connected in SLC700 ?
No
Put the TSP FPCB on SLC700
Yes
R429=High and
C452=2.8V?
No
Replace U406
Yes
When youtouch the window,
does the TOUCH_OUT
react? Or
TA700,R700~R702 is not
high?
No
Replace U700
Yes
Is R732~R735,
ZD700~703 ,C701~C704
placed in board?
No
Replace Resistor, Capacitor,
Zener diode
Yes
Replace the touch module
END
9-30
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
SLC700
1
2
3
4
5
6
7
8
R732
R733
R734
R735
1
2
3
4
5
6
NC
NC
ZD703
ZD 702
ZD 701
ZD 700
TSP_Y
TSP_X
TSP_Y+
TSP_X+
V_DC
VREG_TOUCH_2.8V
U406
3 VIN
VOUT 4
2 GND
1 STBY
TOUCH_PWR_EN
NC 5
GND
6
R429
C451
C452
VREG_TOUCH_2.8V
VREG_TOUCH_2.8V
VREG_TOUCH_2.8V
R700
V D D |R E F A 2
TA700
A1 AUX
C703
TOUCH_OUT
1 NC
2 NC
C702
TOUCH_I2C_SDA
TOUCH_I2C_SCL
PENIRQ- B1
D2 GND
C701
R702
A0
A1 C2
SDA C1
SCL D1
A3 X+
C3
XB3
Y+
D3
Y-
TSP_X+
TSP_X
TSP_Y+
TSP_Y
R701
B2
U700
C704
9-31
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
M O T7 0 0
SLC700
R734
ZD701
C412
R430
R700
U700
L5 0 4
R521
L510
C544
C5 4 6
R5 1 4
L6 0 2
R523
R4 2 9
R702
TA 7 0 0
R6 1 3
C542
R404
C4 5 1
R701
C703
R7 1 6
C70 2
ZD702
C7 3 8
C704
R732
U406
ZD700
R733
Z D 7 0 3 C7 0 1
R735
C452
C539
9-32
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-12. GSM Receiver
CONTINUOUS RX on
RF input : 62CH
RX ON
Cell power : -50dBm
RF input : 62CH
Cell Power : -50 dBm
Yes
No
C100 ≥ -65dBm
Resolder RFS100
Yes
C115 > 1.2V
C110 > 1.2V
C111 < 0.5V
No
Check UCP300
Yes
No
C107 ≥ -68dBM
Resolder PAM100 or Change PAM100
Yes
No
Resolder F100 or Change F100
L102 ≥ -71dBm
Yes
U201 PIN
11,12,13,14 ≥
500mV
No
Check U201
Yes
Check UCP300
END
9-33
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G
G
1
C101
G
3
C100
C137
RFIN
G
2
1
A
C
4
3
2
G
RFS100
C104
C103
4
L100
C102
RFS101
TA100
PAM100
26
10
21
23
VBATT
RX4
RX3
RX2
RX1
WCDMA1
DCS|PCS_IN
GSM_IN
MODE
RSVD
_TXEN
VAPC
BS2
BS1
C107
4
5
6
7
29 GND
C110
1
G
OUT
G
2
5
L101
3
OUT
IN
4
GSM_RX_M
L102
L103
L104
2
3
1
25
GSM_RX_P
F101
9
GND
11
GND
12
GND
13
GND
14
GND
15
GND
16
GND
17
GND
18
GND
19
GND
20
GND
22
GND
24
GND
27
28
ANT
8
F100
C108
1
R103
G
OUT
G
2
5
L105
3
OUT
IN
C111
DCS_RX_M
4
L106
C109
L107
DCS_RX_P
F102
C112
1
2
PCS_RX_M
4
OUT
G
G
L108
3
OUT
IN
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
R1 0 5
R106
R10
R102
C1 3 7
L100
C100
SC2 0 0
C1 0 6
C1 0 5
R107
R104
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
TA 1 0 0
C1 1 1
PAM1 0 0
C114
C102
C1 2 3
C1 3 6
C1 3 0
C1 3 4
C1 1 0
C107
C117
TCX100
C1 1 5
R1 0 3
C108
C1 3 5
C2 2 6
L102
C1 2 4
C112
R1 0 8
C109
L1 0 1
C113
L1 0 4
C233
L1 0 5
C238
L1 0 7
L112
L103
L106
L1 0 8
C240
L116
L109
C241
L1 1 0
C1 2 7
C2 4 4
C2 3 9
C242
C120
C1 2 1
C218
9-34
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-13 GSM Transmitter
CONTINUOUS TX ON
RF Input : 62CH
TX ON (5Level)
PAM100
PIN 23 ≥ 0dBm
No
Check U201
Yes
C115
C110
C111
R107
<
<
>
≥
0.5V
0.5V
1.2V
0.2V
No
Check UCP300
Yes
No
C100
≥ 30dBm
Resolder PAM100 or Change PAM100
Yes
Resolder RFS100 or Change RFS100
END
9-35
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
2
G
G
1
G
3
C101
C100
C137
RFIN
A
G
2
1
3
4
C
G
RFS100
4
C104
C103
L100
C102
RFS101
TA100
PAM100
26
10
21
23
VBATT
RX4
RX3
RX2
RX1
WCDMA1
DCS|PCS_IN
GSM_IN
C107
4
5
6
7
1
G
GOUT
2
5
C110
GSM_RX_M
L102
L103
GSM_RX_P
F101
C108
9
11
12
13
14
15
16
17
18
19
20
22
24
29 GND
4
L104
2
MODE
3
RSVD
1
_TXEN
25
VAPC
BS2
BS1
L101
3
OUT
IN
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
27
28
ANT
8
F100
1
C111
R103
G
GOUT
2
5
L105
3
OUT
IN
DCS_RX_M
4
L106
C109
L107
DCS_RX_P
F102
C112
1
G
2
L108
3
OUT
IN
PCS_RX_M
4
GOUT
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
R1 0 5
R106
R10
R102
C1 3 7
L100
C100
SC2 0 0
C1 0 6
C1 0 5
R107
R104
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
TA1 0 0
PAM1 0 0
C114
C102
C1 2 3
C1 3 6
C1 1 1
C1 1 0
C107
C1 3 0
TCX100
C1 1 5
R1 0 3
C108
C117
C1 3 4
L102
C1 2 4
C112
R1 0 8
C109
L1 0 1
C113
L1 0 4
C233
C1 3 5
C2 2 6
L103
L1 0 5
C238
L1 0 7
L112
L106
L1 0 8
C240
L116
L109
C241
L1 1 0
C1 2 7
C2 4 4
C2 3 9
C242
C120
C1 2 1
C218
9-36
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-14. DCS Receiver
RX ON
RF input : 698CH
Cell Power : -50 dBm
Yes
No
C100 ≥ -65dBm
Resolder RFS100
Yes
C115 > 1.2V
C110 > 1.2V
C111 > 1.2V
No
Check UCP300
Yes
No
C108 ≥ -68dBM
Resolder PAM100 or Change PAM100
Yes
No
Resolder F100 or Change F100
C109 ≥ -71dBm
Yes
U201 PIN
11,12,13,14 ≥
500mV
No
Check U201
Yes
Check UCP300
END
9-37
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G
C102
C103
L100
G
4
G
1
3
C101
C100
C137
RFIN
G
2
1
2
4
3
A
C
G
RFS100
C104
RFS101
TA100
PAM100
GND
G
OUT
G
2
5
4
GSM_RX_M
L103
L102
L104
GSM_RX_P
F101
GND
GND
IN
L101
3
OUT
1
2
3
1
25
24
22
GND
GND
20
19
GND
GND
GND
18
GND
GND
GND
GND
15
16
17
9
C110
11
29 GND
14
GND
BS2
BS1
MODE
RSVD
_TXEN
VAPC
C107
4
5
6
7
RX4
RX3
RX2
RX1
WCDMA1
DCS|PCS_IN
GSM_IN
13
27
28
VBATT
12
26
10
21
23
ANT
8
F100
C108
IN
C111
R103
G
OUT
G
2
5
L105
3
OUT
1
4
DCS_RX_M
L106
C109
L107
DCS_RX_P
F102
C112
IN
4
OUT
G
G
2
L108
3
OUT
1
PCS_RX_M
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
R1 0 5
R106
R10
R102
C1 3 7
L100
C100
SC2 0 0
C1 0 6
R107
R104
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
C1 0 5
PAM1 0 0
C114
C102
C1 2 3
TA 1 0 0
C1 1 1
C1 1 0
C1 1 5
R1 0 3
C107
C1 3 6
TCX100
C1 2 4
C108
C117
C1 3 4
L102
C1 3 0
R1 0 8
C112
L1 0 1
C109
L1 0 4
L1 0 5
L1 0 7
L1 0 8
L1 1 0
C113
C1 3 5
L103
L106
C2 2 6
L109
C120
C1 2 1
C218
9-38
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-15. DCS Transmitter
CONTINUOUS TX ON
RF Input : 698CH
TX ON (0Level)
PAM100
PIN 21 ≥ 0dBm
No
Check U201
Yes
C115
C110
C111
R107
<
>
>
≥
No
0.5V
1.2V
1.2V
0.2V
Check UCP300
Yes
No
C100
≥ 27dBm
Resolder PAM100 or Change PAM100
Yes
Resolder RFS100 or Change RFS100
END
9-39
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G
1
G
G
3
C101
C100
C137
RFIN
G
2
1
4
3
2
A
C
G
RFS100
C103
C104
4
L100
C102
RFS101
TA100
PAM100
26
10
21
23
RX4
RX3
RX2
RX1
WCDMA1
DCS|PCS_IN
GSM_IN
MODE
RSVD
_TXEN
VAPC
BS2
BS1
C107
4
5
6
7
29 GND
C110
1
G
GOUT
2
5
L101
3
OUT
IN
4
GSM_RX_M
L103
L102
L104
2
3
1
25
GSM_RX_P
F101
9
GND
11
GND
12
GND
13
GND
14
GND
15
GND
16
GND
17
GND
18
GND
19
GND
20
GND
22
GND
24
GND
27
28
VBATT
ANT
8
F100
C108
1
C111
R103
G
GOUT
2
5
L105
3
OUT
IN
4
DCS_RX_M
L106
C109
L107
DCS_RX_P
F102
C112
1
4
GOUT
G
2
L108
3
OUT
IN
PCS_RX_M
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
C1 0 6
C1 0 5
R107
R1 0 5
R104
R106
R10
R102
C102
C1 3 7
L100
C100
SC2 0 0
TA 1 0 0
C1 1 1
C1 1 0
C1 1 5
R1 0 3
PAM1 0 0
C114
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
C1 2 3
C1 3 4
TCX100
C1 2 4
C107
C117
C1 3 6
L102
C108
C1 3 5
R1 0 8
C112
L1 0 1
C109
L1 0 4
L1 0 5
L1 0 7
L1 0 8
L1 1 0
C113
C1 3 0
L103
L106
C2 2 6
L109
C120
C1 2 1
C218
9-40
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-16. PCS Receiver
RX ON
RF input : 660CH
Cell Power : -50 dBm
Yes
No
Resolder RFS100
C100 ≥ -65dBm
Yes
C115 > 1.2V
C110 < 0.5V
C111 > 1.2V
No
Check UCP300
Yes
No
C112 ≥ -68dBM
Resolder PAM100 or Change PAM100
Yes
No
C113 ≥ -71dBm
Resolder F100 or Change F100
Yes
U201 PIN
11,12,13,14 ≥
500mV
No
Check U201
Yes
Check UCP300
END
9-41
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
1
C102
C104
C103
L100
4
G
G
3
C101
C100
C137
RFIN
G
2
A
G
1
2
3
4
C
G
RFS100
RFS101
TA100
PAM100
26
10
21
23
WCDMA1
DCS|PCS_IN
GSM_IN
29 GND
C110
1
G
OUT
G
2
5
L101
3
OUT
IN
4
GSM_RX_M
L102
L103
L104
2
3
1
25
MODE
RSVD
_TXEN
VAPC
BS2
BS1
C107
4
5
6
7
RX4
RX3
RX2
RX1
GSM_RX_P
F101
9
GND
11
GND
12
GND
13
GND
14
GND
15
GND
16
GND
17
GND
18
GND
19
GND
20
GND
22
GND
24
GND
27
28
VBATT
ANT
8
F100
C108
1
R103
G
OUT
G
2
5
L105
3
OUT
IN
C111
DCS_RX_M
4
L106
C109
L107
DCS_RX_P
F102
C112
1
G
2
L108
3
OUT
IN
PCS_RX_M
4
OUT
G
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
R107
R1 0 5
R104
R106
R10
R102
C102
C1 3 7
L100
C100
SC2 0 0
C1 0 6
C1 0 5
PAM1 0 0
C114
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
C1 2 3
TA 1 0 0
C1 1 1
C1 1 0
C1 1 5
R1 0 3
C107
C1 3 4
TCX100
C1 2 4
C108
C117
C1 3 6
L102
C1 3 0
R1 0 8
C112
L1 0 1
C109
L1 0 4
L1 0 5
L1 0 7
L1 0 8
L1 1 0
C113
L103
C1 3 5
L106
C2 2 6
L109
C120
C1 2 1
C218
9-42
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-17. PCS Transmitter
CONTINUOUS TX ON
RF Input : 660CH
TX ON (0Level)
PAM100
PIN 21 ≥ 0dBm
No
Check U201
Yes
C115
C110
C111
R107
<
>
>
≥
No
0.5V
1.2V
1.2V
0.2V
Check UCP300
Yes
No
C100
≥ 27dBm
Resolder PAM100 or Change PAM100
Yes
Resolder RFS100 or Change RFS100
END
9-43
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G
A
L100
C102
C103
4
G
1
G
3
C101
C100
C137
RFIN
G
2
1
2
3
4
C
G
RFS100
C104
RFS101
TA100
PAM100
26
10
21
23
RX4
RX3
RX2
RX1
WCDMA1
DCS|PCS_IN
GSM_IN
MODE
RSVD
_TXEN
VAPC
BS2
BS1
C107
4
5
6
7
29 GND
C110
1
G
OUT
G
2
5
L101
3
OUT
IN
4
GSM_RX_M
L103
L102
L104
2
3
1
25
GSM_RX_P
F101
9
GND
11
GND
12
GND
13
GND
14
GND
15
GND
16
GND
17
GND
18
GND
19
GND
20
GND
22
GND
24
GND
27
28
VBATT
ANT
8
F100
C108
1
C111
R103
G
OUT
G
2
5
L105
3
OUT
IN
4
DCS_RX_M
L106
C109
L107
DCS_RX_P
F102
C112
1
4
OUT
G
G
2
L108
3
OUT
IN
PCS_RX_M
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
C224
R202
C208
C213
C2 0 1
C2 0 7
C2 0 0
C211
C206
C204
U201
C210
C116
L202
C212
F1 0 3
C216
C205
C209
C217
C221
R107
R1 0 5
R104
R106
R10
R102
C102
C1 3 7
L100
C100
SC2 0 0
C1 0 6
C1 0 5
PAM1 0 0
C114
0
R101
RFS1 0 0
100
F1 0 1
F1 0 2
C1 2 9
C1 2 3
TA 1 0 0
C1 1 1
C1 1 0
C1 1 5
R1 0 3
C107
C1 3 4
TCX100
C1 2 4
C108
C117
C1 3 6
L102
C1 3 0
R1 0 8
C112
L1 0 1
C109
L1 0 4
L1 0 5
L1 0 7
L1 0 8
L1 1 0
C113
L103
C1 3 5
L106
C2 2 6
L109
C120
C1 2 1
C218
9-44
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-18. WCDMA Receiver
RX ON
RF input : 10700CH
Cell Power : -50 dBm
Yes
No
Resolder RFS100
C100 ≥ -65dBm
Yes
C115 < 0.5V
C110 > 1.2V
C111 < 0.5V
No
Check UCP300
Yes
No
L111 ≥ -68dBM
Resolder PAM100 or Change PAM100
Yes
No
Resolder DUF100 or Change DUF100
L112 ≥ -71dBm
Yes
No
Resolder F200 or Change F200
L206 ≥ -74dBm
Yes
U201 PIN
11,12,13,14 ≥
500mV
No
Check U201
Yes
Check UCP300
Yes
END
9-45
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
G
G
1
C101
G
3
C100
C137
RFI N
G
2
1
2
A
3
4
C
G
RFS100
C104
C103
L100
4
C102
RFS101
TA100
PAM100
8
F100
VBATT
RX4
RX3
RX2
RX1
A NT
26
10
WCDMA1
21
DCS|PCS_IN
23
GSM_IN
27
BS2
28
BS1
1
OUT
IN
G
GOUT
2
5
4
L102
GSM_RX_M
L103
GSM_RX_P
F101
C108
9
11
12
13
14
15
16
17
18
19
20
22
24
C110
L101
3
L104
2
MODE
3
RSVD
1
_TXEN
25
VAPC
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
29 GND
C107
4
5
6
7
1
C111
OUT
IN
R103
G
GOUT
2
5
L105
3
4
DCS_RX_M
L106
C109
L107
DCS_RX_P
F102
C112
1
OUT
IN
G
2
GOUT
L108
3
4
PCS_RX_M
L109
C113
5
L110
PCS_RX_P
R107
GSM_PA_PWR_CTL
GSM_ANT_SEL2_N
C114
C115
L111
TRX_WCDMA_IMT
C122
DUF100
2
ANT
C127
L112
RX 5
UMTS_RX_2100
G
G
G
G
G
G
7 TX
13 46 8 9
L116
9-46
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
C226
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
WPRXSE1_OUT
GCELL_INN
GCELL_INP
EGSM_INN
EGSM_INP
DCS_INN
DCS_INP
GPCS_INN
GPCS_INP
VDDA2
GPS_IN
WDRXLB
WDRXHB1
WDRXHB2
WPRXSE1
VDDA2
WPRXSE2
GSM_RX_M
GSM_RX_P
DCS_RX_M
DCS_RX_P
PCS_RX_M
PCS_RX_P
VREG_RF_S2_2.1V
C239
C233
C238
C240
C241
C242
UMTS_RX_2100
VREG_RF_S2_2.1V
C247
C246
C244
L 204
R204
U201
DRX_IN
N|C
SB DT
VDDA 2
VDDA 1
VDDM
VTUNE2
VDDA 2
RF_ON
VDDA 2
WB _MX_INP
WB _MX_INM
WPRXL B P
WPRXL B M
WPRXHB P
WPRXHB M
WPRXSE2_OUT
VDDA2
TCXO
VDDA1
VDDA1
VTUNE1
VDDA1
VDDA2
VDDA2
VTUNE_GPS
VDDA1
PRX_QP
PRX_QN
PRX_IN
PRX_IP
DRX_QP
DRX_QN
DRX_IP
PDET_IN
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
NC
NC
GND_SL UG
TX_RB IA S
DA C_IREF
TX_QP
TX_QN
TX_IP
TX_IN
VDDA 2
VDDA 2
VDDA 2
HB _RF_OUT3
HB _RF_OUT2
L B _RF_OUT2
HB _RF_OUT1
L B _RF_OUT1
VDDA 2
VDDA 1
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
PWR_DET
UMTS_RX_M_2100
L205
C257
L 207
C260
L206
4
C258
UMTS_RX_P_2100
C2 5 3
R2 0 6
C2 5 7
C210
C116
L202
C216
C2 6 0
C2 4 8
C2 5 8
F1 0 3
C2 5 9
C212
C205
C209
C2 4 7
C217
C221
F1 0 0
F1 0 1
C1 2 9
C1 2 3
TA 1 0 0
CPL1 0 0
C117
C1 3 6
C1 1 1
C1 1 0
C114
R107
R104
R1 0 5
R106
R10 0
C102
R102
C1 3 7
L100
C100
C1 0 6
C1 0 5
PAM1 0 0
R1 1 2
C122
L111
C1 3 4
C1 3 0
C107
C120
TCX100
C1 1 5
C108
R1 0 3
C112
L102
C1 3 5
C109
C1 2 4
R1 0 9
R111
C113
R1 0 8
C233
L1 0 1
C1 2 6
L1 1 4
C128
C238
DUF100
R110
L103
L1 0 4
L112
L1 0 5
L115
L1 0 7
L207
L1 0 8
L116
L1 1 0
L205
L106
C241
C240
C254
L109
C2 2 6
C2 4 4
L2 0 4
R2 0 4
C2 3 9
C242
C1 2 7
C246
F1 0 2
L206
C1 2 1
C218
R101
RFS1 0 0
C259
OUT
2G G
5
F200
F2 0 0
RF_ON
C262
UMTS_RX_P_2100
UMTS_RX_M_2100
C263
OUT
IN
PAM101
C261
1
C254
U201
C253
C248
3
9-47
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-18. WCDMA Transmitter
TX ON (23dBm)
C100 < 21dBm
No
Resolder RFS100 or Change RFS100
Yes
No
C115 < 0.5V
C110 > 1.2V
C111 < 0.5V
Check UCP300
Yes
No
C133 < 0.5V
C132 < 0.5V
C131 > 2.2V
Check UCP300
Yes
L111 < 22dBm
No
Resolder PAM100 or Change PAM100
Yes
No
C126 <24dBm
Resolder DUF100 or Change DUF100
Yes
No
C125 <26dBm
Resolder CPL100 or Change CPL100
Yes
No
Resolder F103 or Change F103
C117 < 2dBm
Yes
No
C116 < 5dBm
Resolder PAM101 or Change PAM101
Yes
Check U201
Yes
END
9-48
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
C2 5 3
U201
C2 6 0
C2 4 8
F1 0 3
C2 5 9
C2 5 8
C216
C205
C209
C2 4 7
C217
C221
R1 0 5
F1 0 2
F1 0 0
F2 0 0
CPL1 0 0
PAM101
TP_ SLEEP_ CLK_ OUT
UCP300
U5 0 9
C300
C322
TP_TX_AGC_ADJ
R6 0 3
R726
C1 2 9
C1 0 5
R605
C1 0 6
R532
C345
TA 1 0 0
C559
C100
R101
TP3 1 1
C55 8
C1 3 6
R102
L100
C1 3 7
R528
R3 2 5
C537
C1 3 1
R530
C1 3 3
C539
C551
R107
R104
R10 0
C309
C1 3 2
C5 4 6
C544
C114
R106
C102
C452
C1 2 3
C1 1 1
PAM1 0 0
R1 1 2
C122
L111
C1 3 4
C1 3 0
C1 1 0
C107
C120
C117
TCX100
C1 1 5
C108
R1 0 3
R1 0 9
C112
L102
C1 3 5
C109
C1 2 4
C1 2 6
L1 1 4
R111
C113
R1 0 8
C233
L1 0 1
C238
DUF100
R110
C128
L103
L1 0 4
L112
L1 0 5
L115
L1 0 7
L207
L1 0 8
L116
L1 1 0
L205
L106
C241
C240
C254
L109
C2 2 6
C2 4 4
L2 0 4
R2 0 4
C2 3 9
C242
C1 2 7
C246
F1 0 1
L206
C1 2 1
C218
R521
C116
C212
RFS1 0 0
R2 0 6
C2 5 7
C210
L202
C321
C346
C557
C326
D7 0 3
U7 0 4
C305
C306
TP308
TP3 0 0
U507
R525
TP3 0 9
R524
R5 1 8
R7 2 5
R519
TP306
TP3 1 0
C540
R538
R526
9-49
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-20. Bluetooth Part
BT Connection disable
No
Check BT function
ON
Enable BT function
Yes
C215 > 2.5V ?
No
Check the circuit connected to
U401 and Check the U401
No
Check the circuit connected to
U401 and Check the U401
Yes
R203 = 32.768KHz ?
Yes
Check the
assembled staus of
ANT 200
No
Resolder or change ANT200
Yes
Exchange U200
END
9-50
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
ANT200
C202
L200
FM_RADIO_ANT
1
2
3
L201
C203
VREG_BT_2.85V
C214
8
9
10
23
VDDR5V
22
VDDR3V
14
FM_ANT
PCM_IN
PCM_OUT
PCM_CLK
PCM_SYNC
U200
I2C_CK
I2C_DA
WLAN_RF_ACTIVE
WLAN_TX_CONFX
WLAN_STATUS
LPO_IN
INTX
VIO
RESET
VREG_CTL
VAFL|VAFR
VAFR|VAFL
25
24
26
27
PCM_DOUT
PCM_DIN
PCM_CLK
PCM_SYNC
17
18
19
21
29
16
20
R203
SLEEP_XTAL_IN
TP202
TP203
BT_RST_N
BT_CONTROL
GND
13
GND
15
GND
28
GND
31
GND
32
GND
33
GND
34
GND
35
GND
36
GND
37
GND
38
GND
39
GND
R203
TP2 0 1
U200
A N T2 0 0
B A T4 0 0
D708
L2 0 3
C2 0 3
R415
R3 1 1
C439
C215
C4 4 0
C214
TP2 0 0
4
5
UART_RX
UART_TX
UART_CTS
UART_RTS
UART_WAKEUP
BT_WAKEUP
C215
11
TP201
30
1
2
3
6
7
BT_ANT
12
L203
D709
9-51
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-52
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
10. Reference data
Reference Abbreviation
- AAC: Advanced Audio Coding.
- AVC : Advanced Video Coding.
- BER : Bit Error Rate
- BPSK: Binary Phase Shift Keying
- CA : Conditional Access
- CDM : Code Division Multiplexing
- C/I : Carrier to Interference
- DMB : Digital Multimedia Broadcasting
- EN : European Standard
- ES : Elementary Stream
- ETSI: European Telecommunications Standards Institute
- MPEG: Moving Picture Experts Group
- PN : Pseudo-random Noise
- PS : Pilot Symbol
- QPSK: Quadrature Phase Shift Keying
- RS : Reed-Solomon
- SI
: Service Information
- TDM : Time Division Multiplexing
- TS : Transport Stream
10-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Reference data
10-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
11. Disassembly and Assembly Instructions
11-1. Disassembly Instructions
1
1) Unscrew 6 points in the rear case.
2
1)After EAR COVER with picture does OPEN
Separate upper/lower column each 2POINTs'
LOCKER.
1) Notice the rear case should not be damaged or 1) Notice the rear case should not be damaged or
scratched.
3
scratched.
Separate REAR after separate left/right each
4
Separate volume key, camera key,power on key.
2 POINTs' LOCKER.
1) Notice the rear case should not be damaged or
scratched.
11-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
5
1)Volume KEY,camera KEY FPCB does take off.
1)Observe to FPCB's that get taken, that tear.
7
6
1)Separate camera connector.
2)Separate camera module in Bracket.
1)Observe to FPCB's that get taken, that tear.
After ACTUATOR of TSP FPCB connector does
8
OPEN, TSP FPCB does take off.
1) Use decomposition groove take off the
motor.
2) Do motor take off in motor connector.
1)Take care so that parts breakdown may not occur.
2)Observe to FPCB's that get taken, that tear.
1)Take care so that motor wire may not damage.
1)Notice the body should not be damaged or
scratched.
11-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
9
Intenna wire does take off.
1)Take care so that Intenna wire may not be damaged.
11
10
Lift PBA, separate connector after does take
off.
1)Take care so that parts breakdown may not occur.
2)Observe to FPCB's that get taken, that tear.
Unscrew 3 POINTs.
12
Separate Intenna and Intenna wire.
1)Take care so that Intenna wire may not be damaged.
11-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
13
1)Separate LCD ASS'Y lifting LCD ASS'Y.
1)Take care so that LCD may not be damaged.
2)Take care so that TSP FPCB may not be damaged.
11-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
11-2. Assembly Instructions
1
1)Connect LCD CONNECTOR.
2
1)After put PBA, put speaker & ear jack
connector.
2)Assemble INTENNA WIRE.
1)Connect so that connector may be sonant.
3
1)Press so that Intena may not grow restless once
more.
1) Screw PBA 2 points.
2) Attach SIDE KEY class.
4
1) Pass TSP FPCB in BRACKET's groove.
2) Set microphone
3) Set LCD ASS'Y
1) Notice the FPCB not be damaged.
1) Notice the FPCB not be damaged.
2) Make MIC be arrived correctly in the groove.
11-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
5
1) SET QCIF camera in the groove.
6
2) SET MEGA camera in the groove.
1) Sets to standard SILK line and inserts
TSP FPCB.
2)After Connect MOTOR, Set Motor in the
3) Connect the Camera
groove.
3) Arranges Motor wire.
1) Make TSP FPCB be inserted perfectly.
1) Notice the FPCB not be damaged
2)Take care so that motor wire may not lean under
board.
7
1) SET Power on key, Camera key.
8
1) Put REAR via the top portion.
2) Insert volume key.
3) Assemble REAR.
1) Notice the rear case should not be damaged or
1)Observe on direction of side key
scratched.
2)Assemble to take all to HOOK.
11-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
5
1) Screw 6 points in the rear case.
1) Notice the rear case should not be damaged or
scratched.
11-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Disassembly and Assembly Instructions
11-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization