Download Whirlpool WGD5800SW0 User's Manual
Transcript
TOP AND CONSOLE PARTS 29"GAS DRYER For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) 1−07 Litho in U.S.A.(LT) 1 Part No. 8181290 TOP AND CONSOLE PARTS For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) Illus. No. 1 Part No. DESCRIPTION Literature Parts 8562582 Instructions, Installation W10042950 Sheet, Cycle Feature 8578183 Use & Care Guide 8576803 Wiring Diagram Following May Be Purchased DO−IT−YOURSELF REPAIR MANUALS Illus. No. 9 10 11 12 13 14 15 16 677818 Dryer 2 3 4 5 6 7 8 3401695 Wire, Jumper (Buzzer On/Off) 694419 Buzzer, Mini Cap, End (L.H.) 8566035 White 8566036 Biscuit 717252 Plug, 2−Way Terminal 8274261 Panel, Rear Console 3405155 Switch, Temperature Cap, End (R.H.) 8566032 White 8566033 Biscuit 17 18 19 21 22 23 24 25 26 Part No. DESCRIPTION 693995 Screw, Hex Washer Head Screen, Lint 8557857 White 8557858 Biscuit 8536939 Clip, Spring 8533971 Screw, 8−18 x 5/16 688983 Screw, 8−18 x 5/8 8312709 Clip−Console 3395683 Connector (Motor) Top 8559800 White 8563660 Biscuit 359625 Screw, 8−18 x 1/2 Knob, Control (3) W10034380 Grey W10034390 Biscuit 3394427 Clip−Harness 3406725 Timer Assembly (60 Hz.) 8558178 Control, Electronic 3391885 Connector, Edge 3397269 Connector−Timer 3401144 Connector, (PTS Relay) 3403499 Connector, 2−Position (Gas Valve) 2 Illus. No. 27 28 31 32 33 34 37 38 39 40 41 42 43 Part No. DESCRIPTION 3403498 Connector, 3−Position (Gas Valve) 3405152 Switch, End Of Cycle 8299891 Harness, Wiring Knob, Push−To−Start W10034770 Grey W10034780 Biscuit 3347243 Connector 6−Circuit 3405154 Switch, Wrinkle Shield 3398094 Switch, Push−To−Start Timer Knob Assembly W10034750 Grey W10034760 Biscuit 94614 Terminal, Female 8566052 Bracket, Control Panel, Control (Includes Illus. 35) 8578860 Grey 8578861 Gold 3936144 Connector 8533951 Screw, Grounding 8181290 CABINET PARTS For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) 8181290 3 CABINET PARTS For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) Illus. No. 1 2 3 4 5 6 7 8 9 10 11 13 14 16 17 Part No. DESCRIPTION 697776 Screw, 10−32 x 5/8 (External Ground) 343641 Screw, 10−16 x 1/2 693995 Screw, Hex Head 8541400 Bracket, Cabinet 3396795 Cover, Block 3404162 Clamp, Motor (W/Shield) 3396805 Panel, Rear 8546676 Clip, Door Spring 3980175 Clamp−Elbow 3406107 Door Switch Assembly 697773 Screw, 6−20 x 7/8 3357011 Screw, 10−16 x 1/2 8541401 Spring, Door (2) 3392100 Foot, Dryer 279810 Foot−Optional (Extended Length) (Package of 2) (Not Included.) 342043 Screw, 10−32 x 3/8 Illus. No. Part No. 18 19 20 21 23 24 25 26 27 28 33 35 36 8530603 8530606 98234 690363 3395197 3977243 685203 3389441 3390731 337189 694091 8066056 8066057 696144 695737 3393549 3977241 DESCRIPTION Cabinet (Includes Illus. 4) White Biscuit Clip, Ground (2) Lock, Front Top (2) Panel Front White Biscuit Clip, Felt Pad (2) Catch, Door Assembly Seal, Door Clip, Hinge (2) Screw, 8−18 x 3/8 Hinge, R.H. Hinge, L.H. Strike, Panel Door, Rear Door, Front White Biscuit 4 Illus. No. Part No. DESCRIPTION 37 Handle, Door W10095180 White W10095190 Biscuit 38 3406129 Seal & Bearing Assembly 39 Plug, Front Panel 3394975 White 3394978 Biscuit 45 344020 Cord, Power 46 3394083 Clip, Front Panel 47 8066217 Hinge, Top (2) 48 691366 Idler & Pulley Assembly 49 8066065 Belt, Drive 50 348780 Base, Motor 51 3400500 Bolt, 5/16−18 x 3/4 52 8066184 Pulley, 60 Hz. 53 8066206 Motor Assembly 60 Hz. 54 660658 Clamp, Motor 55 8318272 Burner Assembly, 60 Hz. (See Pages 7 & 8 For Further Burner Breakdown) 56 341029 Clamp, Pipe 8181290 BULKHEAD PARTS For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) 8181290 5 BULKHEAD PARTS For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) Illus. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 Part No. DESCRIPTION 348368 Lint Chute Assembly 489463 Screw, 8−18 x 5/8 3388703 Washer−Support 347139 Seal, Lint Chute 90767 Screw, 8−18 x 3/8 487909 Screw, 8−15 x 1/2 3392519 Fuse, Thermal 8066086 Drum Hole Plug 8318268 Thermostat, Internal−Bias 694089 Wheel, Blower 8577230 Housing, Blower 3398161 Clip 343641 Screw, 10−16 x 1/2 Illus. No. 14 15 18 19 20 22 23 24 25 26 30 41 Part No. DESCRIPTION 8530285 Box, Heater 3403140 Thermostat, 205 F (96 C) 8066049 Funnel, Burner 3403634 Socket Assembly 3406124 Bulb 3977373 Bracket, Drum Light 3406022 Bracket, Bulkhead 3390647 Screw, 8−18 x 1/2 280010 Kit, Thermal Cut−Off (Includes Illus. 15) 3401707 Wire, Jumper 3976479 Pad, Sensor 690997 Ring, Tri 6 Illus. No. Part No. 42 43 44 46 47 48 49 53 54 55 56 57 58 59 60 61 62 63 3399506 3399507 3397590 348197 3359452 3403414 338906 3402841 692526 97787 3406130 695587 692490 3976434 90296 3403636 339956 696302 DESCRIPTION Shaft, L.H. Shaft, R.H. Roller, Support Washer, Support Nut, 3/8−16 Bulkhead Sensor, Radiant Lens, Drum Light Ring, Bearing Screw, 11−16 x 3/4 Seal, Rear Drum Drum Assembly Baffle, Drum (2) Bracket, Support Clip Baffle, Drum (1) Seal Shield, Exhaust 8181290 8318272 BURNER ASSEMBLY For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) USE WITH TYPE 1 − NATURAL AND TYPE 4 LIQUEFIED PROPANE AND BUTANE GASES BA−150 8181290 7 8318272 BURNER ASSEMBLY For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) USE WITH TYPE 1 − NATURAL AND TYPE 4 LIQUEFIED PROPANE AND BUTANE GASES Illus. Part No. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 20 25 DESCRIPTION 8318272 Burner Assembly 60 Hz. (Type 1) (White Rodgers) 688617 Tube, Burner 694298 Bracket, Ignitor 686590 Ignitor 3393909 Screw & Washer (8−32 x 5/8) 343641 Screw, 10−16 x 1/2 693986 Base, Burner 3387057 Screw, 8−18 x 3/8 Orifice, Burner 234826 Type 1 229742 Type 4 (Butane) 234868 Type 4 (Propane) 8318277 Valve, 60 Hz. (Includes Pipe & Illus. #7) 694421 Screw, 8−32 x 1/2 (2) 694538 Bracket, Coil 694540 Coil, 60 Hz. (2 Terminal) (Main) 694539 Coil, 60 Hz. (Split) (3 Terminal) (Pilot Position) 694424 Leak Limiter 694423 Screw, Regulator Adjustment 694422 Spring, Regulator 239822 Plug, Pipe 341029 Clamp, Pipe Following Parts Not Illustrated 694572 Conversion Kit (Type 1) to Type (4) L.P.G. BA−150 8 8181290 OPTIONAL PARTS (NOT INCLUDED) For Models: WGD5800SW0, WGD5800SG0 (White/Grey) (Biscuit/Gold) Illus. No. Part No. DESCRIPTION ACCESSORY PARTS 279948 Kit, Dryer Repair 346764 Kit, Hold−Down (Gas Dryer Mobile Home Installation) 3406839 Dry Rack 8522199 Kit, Dryer Vent Testing PAINT, TOUCH−UP (1/2oz.) 72017 White 4392899 Biscuit PAINT, PRESSURIZED SPRAY (12 oz.) 350930 White 4392901 Biscuit 350938 Primer, Gray PAINT, BULK (1 qt.) 799344 White (Uncut) 4392900 Biscuit (Uncut) 8181290 9