1
Download Lochinvar Copper-Fin2 User's Manual
Transcript
CPE-RP-07 Replacement Parts List PARTS AND SERVICE DEPARTMENT Nashville, Tennessee 615-889-8900 • Fax: 615-547-1000 www.Lochinvar.com Copper-Fin2® Commercial Pool Heaters CP 991-2071 30 33 32 20 31 36 1 34 2 19 35 CONTROL PANEL 13 18 7 12 5 11 17 4 6 14 15 16 10 8 9 HEAT EXCHANGER ASSEMBLY 26 25 24 23 28 21 22 29 27 GAS TRAIN 3 CPE-RP-07 2 of 4 ITEM NO. PART NO. MODEL NO. DESCRIPTION BURNERS 1 BNR3422 IS MAIN BURNER. *BNR3423 IS MAIN BURNER W/ BARB PRESSURE TAP. *BEFORE SERIAL # E05H00176040. **BNR3430 IS MAIN BURNER W/ COMP. FTG. PRESSURE TAP. **BEGINNING SERIAL # E05H00176040. Model 991 1261 1441 1801 2071 BNR3423* 1 ea 1 ea 1 ea 1 ea 1 ea BNR3430** 1 ea 1 ea 1 ea 1 ea 1 ea BNR3422 10 ea 13 ea 15 ea 19 ea 22 ea GAS TRAIN ASSEMBLIES 2 2 3 3 ORF2421 ORF2418 VAL2076 VAL2413 4 4 5 5 6 7 8 8 8 8 9 10 11 12 13 14 15 16 17 18 19 20 20 20 20 20 21 - PAN3025 PAN3012 RLY2904 RLY2038 RLY2044 RLY2402 WTR2530 WTR30000 WTR2528 WTR30001 WTR2532 WTR2222 WTR2533 WTR20000 RLY2903 RLY3058 TRF2010 SWT2004 MSC2447 RLY2708 RLY2051 RLY2714 SWT2006 HLC2702 PLT3400 PRS2014 PRS2013 PRS2422 PRS2426 PRS2010 GTP3000 HLC2503 22 22 22 22 22 22 22 22 23 23 23 23 23 24 24 24 24 24 25 26 HEX3000 HEX3001 HEX3002 HEX3005 HEX3006 HEX3007 HEX3008 HEX3009 JKE2004 JKE2005 JKE2006 JKE2007 JKE2008 JKE6159 JKE6160 JKE6161 JKE6162 JKE6163 GKT2418 JKD6187 ORIFICE, NAT ORIFICE, LP GAS VALVE, NAT GAS VALVE, LP CPN991-2071 CPL991-2071 CPN991-2071 CPL991-2071 CONTROLS & GAUGES CONTROL PANEL BEGINNING SERIAL# F0600187510 ALL CONTROL PANEL BEFORE SERIAL# F0600187510 ALL ELECTRONIC CONTROL BEGINNING SERIAL# F0600187510 ALL ELECTRONIC CONTROL BEFORE SERIAL# F0600187510 ALL DISPLAY BOARD ALL IGNITION MODULE ALL LOW WATER CUT-OFF, MANUAL RESET (OPTIONAL) PRIOR TO H08H00211349 ALL LOW WATER CUT-OFF, MANUAL RESET (OPTIONAL) BEGINNING H08H00211349 ALL LOW WATER CUT-OFF, AUTO RESET (OPTIONAL) PRIOR TO H08H00211349 ALL LOW WATER CUT-OFF, AUTO RESET (OPTIONAL) BEGINNING H08H00211349 ALL LOW WATER CUT-OFF PROBE (OPTIONAL) PRIOR TO H08H00211349 ALL LOW WATER CUT-OFF PROBE (OPTIONAL) BEGINNING H08H00211349 ALL LOW WATER CUT-OFF BOOT (OPTIONAL) PRIOR TO H08H00211349 ALL LOW WATER CUT-OFF BOOT (OPTIONAL) BEGINNING H08H00211349 ALL 24V RELAY / OTHER OPTIONS ALL RELAY PUMP/MAINT. ALL TRANSFORMER 120VA ALL SWITCH ALL CIRCUIT BREAKER 7AMP ALL 24V RELAY ALL RELAY/ LOUVER ALL TIME DELAY RELAY ALL ON/ OFF SWITCH ALL MANUAL RESET HIGH LIMIT ALL HOT SURFACE IGNITOR ALL AIR PRESSURE SWITCH, NAT BEGINNING SERIAL # F05 CPN991-1261 AIR PRESSURE SWITCH, NAT & LP BEGINNING SERIAL # F05 CPN1441-2071 & CPL991-2071 AIR PRESSURE SWITCH, NAT BEFORE SERIAL # F05 CP991-1261 AIR PRESSURE SWITCH, NAT BEFORE SERIAL # F05 CP1441-2071 AIR PRESSURE SWITCH, LP BEFORE SERIAL # F05 CP991-2071 GAUGE, TEMPERATURE ALL SWITCH, HIGH LIMIT, 110 DEGREE ALL HEAT EXCHANGERS HEAT EXCHANGER CP991 HEAT EXCHANGER CP1261 HEAT EXCHANGER CP1441 HEAT EXCHANGER CUPRO NICKEL CP991 HEAT EXCHANGER CUPRO NICKEL CP1261 HEAT EXCHANGER CUPRO NICKEL CP1441 HEAT EXCHANGER CUPRO NICKEL - STANDARD CP1801 HEAT EXCHANGER CUPRO NICKEL - STANDARD CP2071 V-BAFFLE CP991 V-BAFFLE CP1261 V-BAFFLE CP1441 V-BAFFLE CP1801 V-BAFFLE CP2071 FRAME RUNNER CP991 FRAME RUNNER CP1261 FRAME RUNNER CP1441 FRAME RUNNER CP1801 FRAME RUNNER CP2071 HEAT SHIELD GASKET ALL FRAME END ALL NOTE: CP = POOL HEATER PLEASE HAVE MODEL NUMBER AND SERIAL NUMBER WHEN ORDERING PARTS. CPE-RP-07 3 of 4 ITEM NO. PART NO. 27 28 29 29 30 30 - TST2300 RLV2017 ARM3024PABTE ARM3072PABTE FAN2009 FAN2010 WTR2080 MSC3415 GKT3408 PRS2701 TUB2002 MSC2155 MSC2156 MSC2461 MSC2406 MSC7119 GKT2023 PIP4031 PIP4033 PIP3010 PIP3011 VAL2125 PRS2004 PRS2406 MSC2527 TST2313 31 32 33 34 34 34 34 34 35 35 35 - FIB2204 FIB2205 FIB2228 FIB2231 FIB2232 FIB2233 FIB2220 FIB2224 FIB2234 FIB2236 FIB2255 FIB2472 FIB2456 FIB2457 FIB2458 FIB2459 FIB2455 FIB2258 FIB2260 FIB2257 FIB2259 FIB2256 DESCRIPTION MISCELLANEOUS BULBWELL RELIEF VALVE, T & P PUMP PUMP FAN ASSEMBLY FAN ASSEMBLY FLOW SWITCH SIGHT GLASS KIT GASKET STRIP 45" PRESSURE ALUMINUM TAP TUBING-AIR PRESSURE/GRAY 3/16 x 5/16 TEE, AIR PRESSURE TUBE TEE FITTING, CAP AIR PRESSURE TUBE TUBING SILICONE/CLEAR 1/8" SILICONE TUBING-EPDM 1/8 I.D. BULBWELL CLIP TRANSITION GASKET/FAN, DUCT PIPING LOOP 2 1/2 HORIZONTAL BEGINNING SERIAL # F0600187510 PIPING LOOP 2 1/2 VERTICAL BEGINNING SERIAL# F0600187510 PIPING LOOP 2 1/2 HORIZONTAL BEFORE SERIAL# F0600187510 PIPING LOOP 2 1/2 VERTICAL BEFORE SERIAL# F0600187510 BYPASS VALVE PRESSURE SWITCH/LOW GAS PRESSURE SWITCH/ WATER TOGGLE SWITCH (FOR LWCO OPTION) TEMPERATURE SENSOR LOCH-HEAT TILE FRONT, HEAD, SIDE, PANEL REAR, HEAD SIDE PANEL DIVIDER PANEL INSULATION PAD, FRONT INSULATION PAD, FRONT INSULATION PAD, FRONT LEFT INSULATION PAD, FRONT LEFT INSULATION PAD, FRONT LEFT INSULATION PAD, FRONT RIGHT INSULATION PAD, FRONT RIGHT INSULATION PAD, FRONT RIGHT BACK PANEL BACK PANEL BACK LEFT PANEL BACK LEFT PANEL BACK LEFT PANEL BACK RIGHT PANEL INSULATION PAD, BACK INSULATION PAD, BACK INSULATION PAD, TOP INSULATION PAD, TOP INSULATION PAD, RIGHT SIDE LOCH-HEAT TILE BOTTOM PANELS MODEL NO. ALL ALL CP991-1441 CP1801-2071 CP991-1261 CP1441-2071 ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL 991 1261 1441 1801 2071 1441 1801 2071 991 1261 1441 1801 2071 1441-2071 991-1441 1801-2071 991-1441 1801-2071 ALL 991 Models 36 FIB2206 BOTTOM PANEL POSITION 1* 36 FIB2207 BOTTOM PANEL POSITION 2* 36 FIB2208 BOTTOM PANEL POSITION 3* 1261 Models 36 FIB2211 BOTTOM PANEL POSITION 1* 36 FIB2212 BOTTOM PANEL POSITION 2 & 3* 36 FIB2207 BOTTOM PANEL POSITION 4* 1441 Models 36 FIB2218 BOTTOM PANEL POSITION 1* 36 FIB2207 BOTTOM PANEL POSITION 2 & 3* 36 FIB2219 BOTTOM PANEL POSITION 4* 1801 Models 36 FIB2222 BOTTOM PANEL POSITION 1* 36 FIB2207 BOTTOM PANEL POSITION 2, 3, & 4* 36 FIB2223 BOTTOM PANEL POSITION 5* 2071 Models 36 FIB2226 BOTTOM PANEL POSITION 1* 36 FIB2212 BOTTOM PANEL POSITION 2* 36 FIB2207 BOTTOM PANEL POSITION 3, 4, & 5* 36 FIB2227 BOTTOM PANEL POSITION 6* *DENOTES PLACEMENT ORDER OF COMBUSTION CHAMBER BOTTOM TILE FROM LEFT TO RIGHT (FRONT TO REAR) NOTE: CP = POOL HEATER PLEASE HAVE MODEL NUMBER AND SERIAL NUMBER WHEN ORDERING PARTS CPE-RP-07 4 of 4 © - 10/08 - Printed in U.S.A.
