Download Kenwood KSC-24 User's Manual
Transcript
RAPID CHARGER KSC-24 SERVICE MANUAL © 2001-5 PRINTED IN JAPAN B51-8583-00 (N) 1775 AC adapter (W08-0523-15) : K (W08-0524-15) : E (W08-0939-05) : T Relay terminal (E23-1058-08) x 4 Cabinet (Upper) (A02-3626-08) Photo is K type. Circuit Description ■ Power Supply Section ■ Charging Switch Section 1. The power supply generates constant current (1.1A) from the input voltage (rated 15V DC) from the adapter. 2. IC101 is a DC/DC converter. 3. R117 is a resistor for current detection. 4. R110 and R111 are resistors for no-load voltage detection (non-load voltage : 14V). 5. IC201 is a power supply/reset IC for the microcomputer (IC202). · Power output : 5V · Reset output : “H” (Normal) · After reset : “L” 1. Q201 is a transistor that turns quick charging on and off. 2. Q202 is a transistor that turns trickle charging on and off. 3. The resistor (R204) determines the leakage current. ■ Charging Control Section 1. The microcomputer (IC202) controls the following; · Peak detection (Detected when fully charged, pin 27 of IC202) · Temperature control (Pin 2) · Detection of abnormality, such as a short terminal (Pin 27) · LED control (Red : Pin 21, Green : Pin 22) · Trickle charging (Pin 18) · Quick charging (Pin 17) 2. X201 is an oscillator that generates clocks for the microcomputer (4MHz). ■ Display Section 1. LED201 is a two-color LED that indicates the charging state. 2. Red on ............... Quick charging or warming up Green on ............ Charging is complete Red blinking ....... Abnormal (short terminal, short battery, or open terminal) Charging The charging time for each pack is shown in the table. Battery Pack Battery Type Voltage (Volts) KNB-14 KNB-15A KNB-16A KNB-17A KNB-20N KNB-21N KNB-22N Ni-Cd Ni-Cd Ni-Cd Ni-Cd Ni-MH Ni-MH Ni-MH 7.2 7.2 7.2 7.2 7.2 7.2 7.2 Battery Capacity (mAh) 600 1100 1100 1500 1600 1600 2100 Approximate Charging Time (Minutes) 40 60 60 80 80 80 110 KSC-24 PARTS LIST / EXPLODED VIEW / PC BOARD VIEW Parts List New Ref. No. parts 1 2 Exploded View ✽ : New parts DestiDescription nation Parts No. ✽ ✽ A02-3626-08 A02-3652-08 Cabinet (Upper) Cabinet (Lower) 3 4 E03-0187-08 E23-1058-08 DC jack Relay terminal 5 6 F09-0455-08 F53-0149-08 Thermal fuse Fuse (2A) 7 G13-1546-08 Cushion 1 4x4 A N80-2610-45 Pan head taptite screw 8 – – – W02-1932-08 W08-0523-15 W08-0524-15 W08-0939-05 Electric circuit module AC adapter (120V/60Hz) AC adapter (230V/50Hz) AC adapter (230V/50Hz) ✽ 3 5 6 K E T 8 2 7x2 Ax2 A A 701 PC Board View Electric circuit module (W02-1932-08) Component side view IC201 C201 C203 8 1 + + 5 4 JP7 X201 ± 15 16 R225 R202 IC202 R201 JP6 C202 T DZ202 JA1 R226 + DZ201 D101 R208 R205 R219 R218 D202 R221 R223 C101 R216 R214 R212 D201 + F101 + R204 E C B 125V 2.0A 1 R224 R222 C204 R220 R206 R203 JP2 L101 LED201 R110 C205 R209 R213 R215 R217 30 9 8 Q202 Q201 2 JP5 IC101 JP4 Q204 JP3 C106 C107 C108 Q102 R108 C105 R109 R118 G 117°C TF101 2A R FB101 G D S Q101 C111 R119 D102 C102 + Q203 R103 R106 16 Q103 C103 1 C110 R113 R112 R105 Q206 R111 R101 R102 R104 R107 R115 + R116 DZ101 R114 R211 R210 C104 Q104 R117 JP1 Q205 * : Not installed Vcc : +5V KSC-24 CIRCUIT DIAGRAM 3 KSC-24 SPECIFICATIONS Charging current ....................................... 1100 ± 150mA Source voltage .......................................... Approx. 15V Usable temperature range ........................ 0°C to 40°C (32°F to 104°F) Line voltage (AC adapter) ......................... 120V AC (K) 230V AC (E) 230V AC (T) Dimensions (Body only) ............................ 2-11/64 in (55mm) H x 4-1/8 in (105mm) W x 5-5/16 in (135mm) D Weight (Body only) ................................... Approx. 180g / 6.3oz KENWOOD CORPORATION 14-6, Dogenzaka 1-chome, Shibuya-ku, Tokyo 150-8501, Japan KENWOOD SERVICE CORPORATION P.O. BOX 22745, 2201 East Dominguez Street, Long Beach, CA 90801-5745, U.S.A. KENWOOD ELECTRONICS CANADA INC. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker Str. 15, 63150 Heusenstamm, Germany KENWOOD ELECTRONICS BELGIUM N.V. Mechelsesteenweg 418 B-1930 Zaventem, Belgium KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS U.K. LIMITED KENWOOD House, Dwight Road, Watford, Herts., WD1 8EB United Kingdom KENWOOD ELECTRONICS EUROPE B.V. Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands KENWOOD ELECTRONICS ITALIA S.p.A. Via G. Sirtori, 7/9 20129 Milano, Italy KENWOOD IBERICA S.A. Bolivia, 239-08020 Barcelona, Spain KENWOOD ELECTRONICS AUSTRALIA PTY. LTD. (A.C.N. 001 499 074) 16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113 Australia KENWOOD ELECTRONICS (HONG KONG) LTD. Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD ELECTRONICS TECHNOLOGIES(S) PTE LTD. Sales Marketing Division 1 Ang Mo Kio Street 63, Singapore 569110