Download Sony CDX- L300 CD Player

CDX-L300/L460X
SERVICE MANUAL
US Model
Canadian Model
Ver 1.0 2001. 11
CDX-L300
E Model
CDX-L460X
Photo: CDX-L460X
• The CD sections have no adjustments.
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
22 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
Model Name Using Similar Mechanism
CDX-L250/L430X
NEW
CD Drive Mechanism Type
MG-393X-121//K
MG-393XA-121//K
Optical Pick-up Name
KSS-720A
Harmonic distortion at 1 kHz
0.7% (stereo),
0.5% (mono)
Separation
33 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
CD player section
Tuning range
Signal-to-noise ratio
90 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Laser Diode Properties (CDX-L300)
Material
GaAlAs
Wavelength
780 nm
Emission Duration
Continuous
Laser output power
Less than 44.6 µW*
* This output is the value measured at a distance
of 200 mm from the objective lens surface on the
Optical Pick-up Block.
Tuner section
CDX-L300:
530 – 1,710 kHz
CDX-L460X:
AM tuning interval:
9 kHz/10 kHz
switchable
531 – 1,602 kHz
(at 9 kHz step)
530 – 1,710 kHz
(at 10 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
30 µV
Power amplifier section
FM
Tuning range
CDX-L300:
87.5 – 107.9 MHz
CDX-L460X:
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108 MHz
(at 50 kHz step)
87.5 – 107.9 MHz
(at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz
Usable sensitivity
11 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
65 dB (stereo),
68 dB (mono)
9-873-402-01
Sony Corporation
2001K0400-1
© 2001. 11
e Vehicle Company
Published by Sony Engineering Corporation
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 45 W × 4 (at 4 ohms)
– Continued on next page –
FM/AM COMPACT DISC PLAYER
1
CDX-L300/L460X
General
Outputs
Tone controls
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Audio output
Power amplifier control lead
(CDX-L300)
Power antenna relay
control lead (CDX-L300)
Power aerial relay control
lead (CDX-L460X)
Bass ±10 dB at 20 Hz (CDX-L300)
Treble ±10 dB at 20 kHz (CDX-L300)
Bass ±9 dB at 100 Hz (CDX-L460X)
Treble ±9 dB at 10 kHz (CDX-L460X)
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 176 mm
(7 1/8 × 2 × 7 in.)
(w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.)
(w/h/d)
Approx. 1.2 kg (2 lb. 10 oz.)
Parts for installation and
connections (1 set)
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up block
Note (CDX-L460X)
This unit cannot be connected to a digital
preamplifier or an equalizer.
Design and specifications are subject to change without
notice.
semi-fixed resistor
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2501-063-1)
CD-RW test disc TCD-W082L (Part No. J-2501-063-2)
CDX-L300/L460X
Notes for Inspection of the Mechanism Deck
The CDX-L300 uses two types of mechanism decks.
Former type: MG-393X-121//K
New type: MG-393XA-121//K
The CDX-L460X only uses the MG-393XA-121//K.
When inspecting and/or serving, check the model No. printed on
the SERVO board.
- SERVO BOARD (SIDE A) -
MG-393X//K:MG-393X-121//K
MG-393XA//K:MG-393XA-121//K
3
CDX-L300/L460X
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
MG-393X-121//K
• Connect the MAIN board (CNP701) and the SERVO board (CN1)
with the extension cable (Part No. J-2502-011-1).
MAIN BOARD CNP701
SERVO BOARD CN1
J-2502-011-1
MG-393XA-121//K
• Connect the MAIN board (CNP701) and the SERVO board (CN1)
with the extension cable (Part No. J-2502-062-1).
MAIN BOARD CNP701
SERVO BOARD CN1
J-2502-062-1
4
CDX-L300/L460X
TABLE OF CONTENTS
1. GENERAL
Location of controls (L300) .................................................... 6
Location of controls (L460X) .................................................. 6
Getting Started ......................................................................... 6
CD Player ................................................................................ 7
Radio ....................................................................................... 7
Other Functions ....................................................................... 8
Additional Information ............................................................ 8
Connections (L300) ................................................................. 9
Connections (L460X) ............................................................ 11
2. DISASSEMBLY
2-1. Front Panel Assy ............................................................... 13
2-2. CD Mechanism Block ....................................................... 14
2-3. Main Board ....................................................................... 14
2-4. Heat Sink ........................................................................... 15
2-5. Chassis (T) Sub Assy ........................................................ 15
2-6. Lever Section ..................................................................... 16
2-7. Servo Board ....................................................................... 16
2-8. Shaft Roller Assy .............................................................. 17
2-9. Floating Block Assy .......................................................... 17
2-10. Optical Pick-up Block ....................................................... 18
3. DIAGRAMS
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
IC Pin Description ............................................................. 19
Block Diagram –CD Section– ........................................... 21
Block Diagram –Tuner Section– ....................................... 22
Block Diagram –Display Section– .................................... 23
Circuit Boards Location .................................................... 24
Schematic Diagram
–CD Mechanism Section (MG-393X-121//K)– ................ 25
3-7. Printed Wiring Boards
–CD Mechanism Section (MG-393X-121//K)– ................ 26
3-8. Printed Wiring Boards
–CD Mechanism Section (MG-393XA-121//K)– ............. 28
3-9. Schematic Diagram
–CD Mechanism Section (MG-393XA-121//K)– ............. 30
3-10. Printed Wiring Board –Main Section– .............................. 31
3-11. Schematic Diagram –Main Section (1/2)– ........................ 32
3-12. Schematic Diagram –Main Section (2/2)– ........................ 33
3-13. Printed Wiring Board –Display Section– .......................... 34
3-14. Schematic Diagram –Display Section– ............................. 35
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
4-7.
4-8.
Chassis Section ................................................................. 38
Front Panel Section ........................................................... 39
CD Mechanism Section (1) (MG-393X-121//K) .............. 40
CD Mechanism Section (2) (MG-393X-121//K) .............. 41
CD Mechanism Section (3) (MG-393X-121//K) .............. 42
CD Mechanism Section (1) (MG-393XA-121//K) ........... 43
CD Mechanism Section (2) (MG-393XA-121//K) ........... 44
CD Mechanism Section (3) (MG-393XA-121//K) ........... 45
5. ELECTRICAL PARTS LIST ........................................ 46
5
CDX-L300/L460X
SECTION 1
GENERAL
(L300)
6
This section is extracted
from instruction manual.
(L460X)
CDX-L300/L460X
7
CDX-L300/L460X
8
CDX-L300/L460X
• Connections (L300)
9
CDX-L300/L460X
10
CDX-L300/L460X
• Connections (L460X)
11
CDX-L300/L460X
12
CDX-L300/L460X
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-5.
CHASSIS (T) SUB ASSY
(Page 15)
CD MECHANISM BLOCK
(Page 14)
2-6.
LEVER SECTION
(Page 16)
2-3.
MAIN BOARD
(Page 14)
2-8.
SHAFT ROLLER ASSY
(Page 17)
2-4.
HEAT SINK
(Page 15)
2-9.
FLOATING BLOCK ASSY
(Page 17)
2-10.
OPTICAL PICK-UP BLOCK
(Page 18)
2-1.
FRONT PANEL ASSY
(Page 13)
2-2.
2-7.
SERVO BOARD
(Page 16)
Note : Follow the disassembly procedure in the numerical order given.
2-1. FRONT PANEL ASSY
claws
2 claws
1 claws
4 front panel assy
3 CNP801
13
CDX-L300/L460X
2-2. CD MECHANISM BLOCK
8 bracket (CD)
6 CD mechanism block
7 PTT 2.6x6
2 PTT 2.6x6
4
1 PTT 2.6x6
3 PTT 2.6x6
5 CNP701
2-3. MAIN BOARD
5 MAIN board
3 screw (+BTT)
4 screws (+BTT)
2 PTT 2.6x8
1 PTT 2.6x8
14
CDX-L300/L460X
2-4. HEAT SINK
6 heat sink
5 PTT 2.6x8
4 PTT 2.6x8
3 PTT 2.6x12
2 PTT 2.6x8
1 PTT 2.6x8
2-5. CHASSIS (T) SUB ASSY
2 P 2x3
3 P 2x3
1 Unsolder the
lead wires.
4 chassis (T) sub assy
black
red
white
15
CDX-L300/L460X
2-6. LEVER SECTION
5 guide (disc)
6 lever (R)
3 tension spring (LR)
7 lever (L)
1 special screw
2 IN SELF SW board
4 claws
2-7. SERVO BOARD
7 SERVO board
6 special screw
5 special screws
2 Removal the solders.
8 connector
1 CN3
3 P 2x3
4 loading motor assy
optical pick-up block
16
CDX-L300/L460X
2-8. SHAFT ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
3 retaing ring (RA)
4 shaft retainer
shaft retainer
retaing ring (RA) arm washer
arm
washer
shaft retainer
Fig. 1
5 shaft roller assy
2 arm (roller)
1 tension spring (RA)
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1)
8 compression spring (FL)
4 Fit lever (D) in the
direction of the arrow.
5 Turn loading ring in the
direction of the arrow.
2 damper (T)
3 damper (T)
17
CDX-L300/L460X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
4 P 2x3
5 spring (feed), plate
2 sled motor assy
6 shaft (feed) assy
18
3 optical pick-up block
CDX-L300/L460X
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTION
• IC801 µPD780024AGK-B40-9ET (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
1
D SW
I
Down switch detection input
Pin Description
2
3
IN SW
PH3
I
I
Disc in switch detection input
PH3 detection input (Not used in this set)
4
5
LM LD
LM EJ
O
O
Loading motor drive output (Loading)
Loading motor drive output (Eject)
6
7
A ATT
ATT
O
O
Power amplifier mute control output
Line out mute control output
8
9
BEEP
VSSO
O
—
BEEP output
Ground
10
11
VDDO
VOL CLK
—
O
Power supply pin (+5 V)
Electric volume clock output
12
13
VOL DO
VOL CE
O
O
Electric volume data out output
Electric volume chip enable output
14
15
AM ON
FM ON
O
O
Tuner AM power supply control output
Tuner FM power supply control output
16
17
NOSE
PLL DI
I
I
Front panel attachment detection input
PLL IC data input
18
19
LCD DO
LCD CE
O
O
LCD data output
LCD chip enable output
20
21
LCD CLK
PLL CLK
O
O
LCD clock output
PLL IC clock output
22
23
24
PLL DO
PLL CE
VDD1
O
O
—
PLL IC data output
PLL IC chip enable output
Power supply pin (+5 V)
25
26
AVSS
ST IND
—
I
Ground
FM STEREO detection input
27
28
FUN SEL
S METER
I
I
Function select input
S meter signal input
29, 30
31
KEY0, 1
TEL ATT
I
I
A/D key input 0, 1
Attenuator signal input
32
33
DST SEL
TEST
I
I
Destination select input
Force test mode input
34
35
AVREF
AVDD
—
—
A/D converter power supply pin (+5 V)
A/D converter power supply pin (+5 V)
36
37
RESET
XT2
I
O
Reset input
Sub clock output (32.768 kHz)
38
39
XT1
IC
I
—
Sub clock input (32.768 kHz)
Connect to Ground in this set.
40
41
X2
X1
O
I
Master clock output (8.38 MHz)
Master clock input (8.38 MHz)
42
43
VSS1
KEY ACK
—
I
Ground
Key acknowledge detection input
44
45
SIRCS
SELF SW
I
I
SIRCS input
Self switch detection input
46
47
BU IN
AD ON
I
O
Backup power supply detection input
Key power supply control output
48
49
ILL ON
AMP ON
O
O
Illumination power supply control output
Amplifier remote power supply control output
50
51
CDM ON
XCD ON
O
O
CD mechanism deck power supply control output
CD DSP IC 16 MHz X’tal ON/OFF control output
52
TU ON
O
Tuner power supply control output
19
CDX-L300/L460X
Pin No.
53
Pin Name
P.ON
I/O
O
54
55
X SO
X SI
O
I
CD DSP IC serial data output
CD DSP IC serial data input
56
57
X SCK
RFOK
O
I
CD DSP IC serial clock output
CD servo IC RFOK signal input
58
59
X RST
ACC IN
O
I
CD DSP IC reset control output
Accessory power supply detection input
60
61
AO
STB
O
O
CD servo IC command/pallameter discrimination signal output
CD servo IC data strobe signal output
62
63
XEN
L SW
O
I
CD DSP IC X’tal control output
Limit switch detection input
64
PH1
I
PH1 detection input (Not used in this set)
20
Pin Description
System power supply control output
CDX-L300/L460X
3-2. BLOCK DIAGRAM — CD SECTION —
RF AMP,DIGITAL SERVO
DIGITAL SIGNAL PROCESSOR
IC1(MG-393X-121//K)
IC1(MG-393XA-121//K)
OPTICAL PICK-UP
KSS-720A
A
84
C
85
(Page 22)
MAIN
SECTION
B
D
RF
EQ
A
B
82
DSUB CODE
PROCESS
C
I-V
CONV.
D
LOUT
16
ROUT
12
D/A
CONV
EFM
DEMOD
83
FORCUS
ERROR
I/F
E
E
87
F
86
PD
97
PD
SERVO
CTL
PACK
52
TSTB
56
TSCK
55
TSI
54
SI
8
SO
7
SCK
6
STB
5
AO
4
RST
3
RFOK
APC
XTALEN
OSC
LD
DRIVE
Q1
SYSTEM CONTROL
IC801(1/3)
54 X_SO
55 X_SI
56 X_SCK
61 STB
60 A0
58 X_RST
2
57 RFOK
9
62 XEN
FOCUS
COIL
FCS+
TRK+
TRACKING
COIL
TRK-
15
16
17
18
FOCUS
COIL
DRIVE
TRACKING
COIL
DRIVE
26
23
MD
62 63 64 65
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING MOTOR DRIVE
IC2(MG-393X-121//K)
IC2(MG-393XA-121//K)
FCS-
SD
LD
TD
98
23
24
X1
16.9344MHz
FD
1 D_SW
SW1
(DOWN)
45 SELF_SW
SW2
(SELF)
TD
2 IN_SW
SW3
(DISC IN)
M902
(SLED)
A
A5V
FD
LD
F
TRACKING
ERROR
CDL
R-CH
M
SL-
SLED
MOTOR
DRIVE
5
12
SPINDLE
MOTOR
DRIVE
6
LD9
LD+ 10
LOADING
MOTOR
DRIVE
SL+
M901
(SPINDLE)
M
M903
(LOADING)
M
SP+
SP-
13
14
11
63 L_SW
SW4
(LIMIT)
SD
IC902
RESET 36
1
MD
1
RESET
2
U_COM+5V
S581
(RESET)
LOAD
4 LM _LO
EJECT
2
5 LM_ EJ
A_5V
POWER
CONTROL
Q905,906
REG
Q910,D910
D909
POWER
CONTROL
Q921
AU_5V
D_5V
REG
Q907,D908
DR_6V
21
50 CDM ON
BATT
21
51 XCD_ON
• Signal path
:CD
• R-ch is omitted due to
same as L-ch.
CDX-L300/L460X
3-3. BLOCK DIAGRAM — TUNER SECTION —
PJ401
L
AUDIO OUT REAR
R
R-CH
A
TUNER UNIT
TU601
CNJ601
(ANTENNA)
L-CH 16
R-CH 17
1 AM_ANT DET_OUT 24
CD
SECTION
POWER AMP
IC101
ELECTRONIC VOLUME
IC401
(Page 21)
CDL
LF OUT 5
12
5
3
1 FL+
9 FL–
LR OUT 4
11
9
7
2 RL+
10 RL–
14 L5
18 L1
2 FM_ANT
R-CH
17 L2
21 R2
Q102
MUTE
RF OUT 33
RR OUT 34
8 LCL
FM/AM_OSC 11
15 FM_VCO
16 AM_VCO
FM_VT 6
AM_VT 14
OSC-IN 19
IF_COUNT 20
TU+B
FM POWER
CONTROL
Q605,606
18 FM_CP
19 VT
20 AM_CP
2
10
13
11
3 RR+
11 RR–
ATT
BEEP
P.ON
A_ATT
D402
7
8
53
6
DELAY
BATT
ACC
CHECK
Q902
ACC IN 59
6
4
5
3
17
22
21
23
PLL_DI
PLL_DO
PLL_CLK
PLL_CE
7 ACC
15 TEST
TEST 33
BATT
OSC
SEEK
IFC
MONO
R-CH
MUTE
CONT
Q401,402
11 VOL_CLK
12 VOL_DO
13 VOL_CE
D_OUT
D_IN
CK
CE
4 FR+
12 FR–
4 STBY
22 MUTE
AMP POWER
CONTROL
Q911,917
5 AMP REM
6 ANT REM
AMP_ON 49
XO 1
GND
Q909
X601
10.25MHz
13
• FM/AM_VCC
25
S_METER 21
SD/ST_IND 22
8
TU_ON 52
XI 24
BACK-UP CHECK
Q903,904,D906,907
BU_IN 46
17
19
28 S_METER
26 SD_IND
TU+B
TUNER+8V REG
Q912,913,D913
F901
10A
12 FM_VCC
18
(FREQUENCY
SELECT ) SW801
COM+8V
AM POWER
CONTROL
Q603,604
16 AUX-IN
R-CH
SYSTEM CONTROL
IC801 (2/3)
PLL
IC601
Q101
MUTE
R-CH
2 CE
1 DI
36 CL
AM_DX/LCL 3
CNP501
FM 200k
AM 10k
32 DST_SEL
9 AM_VCC
FM_ON 15
AM_ON 14
FM 50k
AM 9k
L460X
16 +B (BATT)
COM+8V REG
Q918,919,929,D923
U_COM+5V
U_COM+5 V REG
Q920,D930,D999
BATT
• Signal path
L300
:FM
:AM
:CD
• R-ch is omitted due to
same as L-ch.
22
22
CDX-L300/L460X
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
SYSTEM CONTROL
IC801 (3/3)
KEY 0
KEY MATRIX
S501-511,
S512-521
KEY 1
29 KEY 0
30 KEY 1
LCD DRIVE
IC551
1
|
SEG1 23
|
•
SEG52 25
|
53
62 DATA
CLK
61 CLK
CE
60 CE
LCD DO 18
LCD CLK 20
LCD CE 19
D914
LCD
LCD501
COM1 64
•
43 KEY ACK
INH
KEY
ACTIVE
Q916
57
47 AD ON
INITIAL
RESET
D552
ILL ON 48
ILL POWER
CONTROLLER
Q914
BATT
X802
32.768kHz
37 XT2
38 XT1
•
COM2 63
X2 40
X1 41
X801
8.38MHz
ILL+B
ILL + B
D561-581
KEY
(ILLUMINATION
)
SWITCH
Q915
BACK
( LCDLIGHT
)
LED501-504
23
CDX-L300/L460X
3-5. CIRCUIT BOARDS LOCATION
SERVO board
IN SELF SW board
SPEAKER board
tuner unit
(TU601)
DISPLAY board
MAIN board
SL SW board
• Waveforms
— Servo Board —
(MG-393X-121//K)
• Waveforms
— Servo Board —
(MG-393XA-121//K)
(MODE: CD PLAY)
(MODE: CD PLAY)
1
1
1
4.4Vp-p
wd
16.9344MHz
(XTAL)
IC1
2
wd
32.768kHz
(XTAL)
IC801
2
22.7µsec
(PACK)
IC1
3
ts
1.2Vp-p
uj
8.38MHz
1.2Vp-p
(RFO)
IC1
4
uj
(RFO)
4
0V
0V
Approx. 1Vp-p
IC1
oa
Approx. 1Vp-p
(FEO)
IC1
5
oa
(FEO)
5
0V
Approx. 400mVp-p
IC1
od
(TEO)
5Vp-p
IC801
(PACK)
3
IC1
(XT2)
3Vp-p
22.7µsec
ts
ej
2
3Vp-p
IC1
3.8Vp-p
4.4Vp-p
16.9344MHz
IC1
24
— Main Board —
0V
Approx. 400mVp-p
IC1
od
(TEO)
r;
(X2)
CDX-L300/L460X
3-6. SCHEMATIC DIAGRAM
• Refer to page 24 for Waveforms.
— CD MECHANISM SECTION (MG-393X-121//K) — • Refer to page 36 for IC Block Diagrams.
IC B/D
IC B/D
(Page 33)
Note:
• Voltage and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : CD PLAY
25
25
CDX-L300/L460X
3-7. PRINTED WIRING BOARDS
• Refer to page 24 for Circuit Boards Location.
— CD MECHANISM SECTION (MG-393X-121//K) —
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : CD
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
26
26
CDX-L300/L460X
• Semiconductor
Location
(Page 31)
27
27
Ref. No.
IC1
IC2
Location
D-2
G-2
Q1
B-3
CDX-L300/L460X
3-8. PRINTED WIRING BOARDS
• Refer to page 24 for Circuit Boards Location.
— CD MECHANISM SECTION (MG-393XA-121//K) —
12
11
10
9
8
7
6
5
4
3
2
1
A
B
CN2
C
D
E
F
G
H
SW1
I
J
28
28
CDX-L300/L460X
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
• Semiconductor
Location
TP63
C1
C5
R30
TP82
C4
TP48
TP9
TP60
FB7 TP50
TP47
R22
TP64
R3
R26
TP52
SW3
TP12
C6
R5
C9 C10
C11
C8
TP59
FB6
TP83
TP11
TP8
TP51
D
C43
C3
TP80
C
TP81
Q1
TP79
TP66
TP84
R29
R21
TP71
TP56
TP70
C18
C14
TP23
C41
R19
TP61
C27
TP88
C34
TP74
C29
TP68
TP75
C36
TP49
X1
C38
FB4
TP55
TP18
TP30
G
R24
TP73
TP21
TP32
R25
TP6
R7
R6
R15
TP91
TP86
C22
H
TP90
TP87
C37
TP26
TP29
TP19
TP4
C30
TP20
CN3
TP5
IC2
C21
TP54
R14
R10 R12
TP53
I
TP41
TP42
C44
SW4
TP44
TP43
TP40
FB2
TP39
R20
TP85
C35
TP37
TP38
TP92
C26
FB3
TP45
TP35 TP46
TP34
TP36
TP57
F
SW2
TP25
IC1
C45
TP76
TP69
R8
C24
TP22
TP24
C25
C40
TP58
E
C20
C19
C23
R9
C17
FB1
R17
TP72
C16
R18
(Page 31)
TP89
C15
CN1
TP10
C13
TP62
Location
E-7
H-7
Q1
C-6
TP78
TP77
TP7
B
Ref. No.
IC1
IC2
TP28
TP3
TP17
TP2
TP27
TP16
TP1
J
29
29
CDX-L300/L460X
3-9. SCHEMATIC DIAGRAM
• Refer to page 24 for Waveforms.
— CD MECHANISM SECTION (MG-393XA-121//K) — • Refer to page 36 for IC Block Diagrams.
CN2
C20
TP8
C19
TP77
TP78
R3
R29
R30
R26
C23
R9
C1
C5
C43
C4
C6
R8
C18
C3
TP89
TP79
TP80
FB4
C24
TP88
TP9
TP22
TP23
TP24
TP25
Q1
FB2
C35
C14
TP81
TP82
TP83
TP84
TP45
TP44
TP43
TP42
TP41
TP10
C13
C11
R5
TP40
TP39
TP38
TP37
SW4
TP7
C15
IC1
TP46
C10
TP36
C38
TP12 C9
TP11
CN13
CN3
C8
TP85
TP35
TP34
M902
C36
C16
M901
IC B/D
TP92
C25
C44
C29
CN1
C17
FB1
C40
R18
X1
SW1
C34
FB3
C45
C26
C27
C41
TP1
TP5
R19
R20
TP6
R17
TP4
TP2
SW2
SW3
TP3
R7
TP30
TP32
TP61
TP76
TP60
TP75
TP59
TP74
TP58
TP73
TP57
TP72
TP56
TP71
TP55
TP70
TP54
TP69
TP53
TP68
TP52
TP66
TP21
TP18
R15
R24
R25
TP51
R12
R22
R10
FB7
TP50
TP64
TP49
R14
C22
IC2
R21
C21
TP90
C30
R6
TP17
TP20
TP16
TP19
TP91
TP48
TP63
TP47
TP62
C37
TP27
TP29
TP26
TP28
IC B/D
TP87
M903
TP86
Note:
• Voltage and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : CD PLAY
30
30
FB6
(Page 33)
CDX-L300/L460X
3-10. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 24 for Circuit Boards Location.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
PJ401
CNJ601
Q918
JW53
JW52
JW54
JW56
JW55
D907
D908
C905
JR929
JW72
Q913
Q912
(MG-393X )
C909
(Page 27)
D913
R917
Q920
Q911
C844
JW98
R407
JW94
Q929
R711
R933
R932
JW126
JW66
JW95
D930
D999
R931
(MG-393XA)
C914
R918
R930
R919
JW81
SW801
IC902
C916
D914
JR903
JW80
J
(Page 34)
31
31
R929
R926
R927
R928
R925
R924
R920
JW82
JW78
R819
C915
JW77
Q916
R818 R817
JW110
JW76
(Page 29)
Q915
Q914
JW74
JW73
JW75
C804
C802
JW69
R802
C803
JW68
JW8
R815
R923
R922
R822
R840
R813
C806
X801
C846
R921
JW71
02
X8
R842
R841
C810
JW7 C812
R811
R812
R810
R843
C849
IC801
C801
R807
R808
R408
R806
JW90
JW89
R912
Q921
Q906
R710
R934
JW85
JW96
R824
JW5
D923
Q905
R707
R708
R709
JW67
JW9
JW10
JW107
D906
R909
Q903
Q910
R913
JW93
Q919
JW23
JW22
JW21
R809
L702
C704
JW86
Q917
D909
C919
JW91
JW87
TH901
JW63
L701
C707
R705
R706
C845
D901
D916
Q402
R401
Q902
D445
Q401
C702
JW61
JW62
JW79
C218
L703
JW92
JW88
R911
JW65
Q904
Q909
JW105
JW12
R910
R908
C703
JW108
R615
C904
D910
R714
R716
JW106
C652
L901
C907
C701
JW64
JW29
JW30
C119
C118
JW97
R610
JR1
D903
R907
JW11
JW20
Q604
Q606
C841
C842
JW4
C902
JR901
R404
D446
C706
R814
JW3
JW2
JW44
C432
D918
JW41
C117
C626
JW19
JW18
C809
D917
Q907
JW58
CNP701
R617
R906
JW59
R704
R605
CNP802
JW1
JW39
JW38
Q201
R210
X601
L604
R616
JW26
D810
I
R444
JW27
D904
JW50
JW57
JW24
C623
C625
R604
R628
C631
C624 R619
C618
C621
C622
JW16
JW17
JW15 C651
IC601
D922
D915
JW31
JW99
C608
R608
Q603
H
R110
C104
C103
C615
C617
C619
C848
C633
C614
JW48
R901
C215
C217 JW25
D666
R607
C650
R621
Q605
R623
JW14
JW13
C620
R611
D919
JW60
C847
R613 L603 R612
C613
C606
R622
C219
C116
C115
JR602
R618
D604
R609
R620
C113
C611 R606
R601
R213
R215
C216
C627 C610
C612
C605
IC401
R115
C114
R603
R602
C214
C213
C111
JW6
C609
R614
JW32
G
R113
JW84
JW33
C604
C435
JW47
R410 D402
C426
C210
C211
C208
L601
C666 D601
E
JW28
JW46
JW49
D401
C110
JR610
C603
C102
C203
C204
JW34
C108
C635
R209
CP601
TU601
D
C202
JR101
C843
L605
R207
JW45
JW40
R205
Q202
Q102
Q101
JW36
JW35
L669
C401
R106
R109
C901
JW83
R208
D920
C201
R108 JW37
C
CNP501
JW42
C101
R105
R107
JW51
D921
IC101
R206
B
F
JW43
C407
D444
C105
C205
A
• Semiconductor Location
Ref. No. Location
Ref. No.
IC801
D401
D-5
IC902
D402
D-6
D444
D-6
Q101
D445
D-6
Q102
D446
D-6
Q201
D604
E-2
Q202
D666
F-4
Q401
D810
I-4
Q402
D901
C-9
Q603
D903
C-9
Q604
D904
C-9
Q605
D906
D-9
Q606
D907
D-9
Q902
D908
D-10
Q903
D909
F-10
Q904
D910
E-7
Q905
D913
G-11
Q906
D914
I-8
Q907
D915
C-8
Q909
D916
C-6
Q910
D917
C-8
Q911
D918
C-6
Q912
D919
C-8
Q913
D920
B-7
Q914
D921
B-7
Q915
D922
C-8
Q916
D923
F-8
Q917
D930
H-9
Q918
D999
G-10
Q919
Q920
IC101
B-6
Q921
IC401
D-4
Q929
IC601
F-3
Location
H-7
I-9
C-3
C-3
C-4
C-4
D-6
D-6
H-3
H-4
H-2
H-4
E-9
E-9
E-9
G-8
G-9
C-10
E-9
E-8
G-9
G-9
G-10
H-9
H-10
H-8
E-10
F-8
F-8
G-9
F-9
F-8
CDX-L300/L460X
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 36 for IC Block Diagrams.-
PJ401
C105
C205
D444
C401
IC101
R105
R401
Q101
C103 R109
R107
R444
R108
C104
D922
C201
R206
Q102
R110
D921
D920
C202
R106
D919
D918
R205
L605
Q201
C203 R209
R207
CP601
L601
R410
Q401
R208
C666
C204
Q202
R210
D917
D916
CNP501
C101
D446
D915
Q402
L669
C432
C407
JR610
D601
JR101
R404
C635
C426
R408
C603
R407
C606
C605
C604
JR602
R602
R603
C609
C610
IC401
C435
R613
IC601
R620
IC B/D
R612
R606
R601
R611
C611
R906
L901
D666
D401
L603
R623
R619
C614
C615
C631
R215
R607
R608
C617
C618
C210
C211
C213
C214
C215
JW13
C216
C108
R113
C111
C113
C114
R115
C116
C115
C901
R901
C651
C110
D904
R621
R213
D903
C650
D901
C208
C612
C613
C902
R622
C633
TU601
D445
CNJ601
C102
D402
C217
C620
R610
C117
C218
C622
R609
R628
C626
C621
C619
IC B/D
C624
L604
C219
C623
X601
C625
C707
R605
R604
C706
C119
C118
R716
R714
C608
C848
R614
Q605
Q603
R618
R616
R617
R615
D604
Q606
C627
Q604
C842
C841
(Page 33)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
32
32
CDX-L300/L460X
3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 24 for Waveforms.
(Page 32)
L703
(Page 25)
(MG-393X)
(MG-393XA)
C847
C701
(Page
30)
C702
L701
C703
Q903
L702
C704
Q902
D906
R908
R704
R705
R706
R910
D907
Q904
R711
R710
R709
R707
R909
C904
R907
R911
R708
CNP701
C844
JR901
Q917
Q919
C802
TH901
X802
C849
Q918
R934
R933
C806
R932
Q929
C919
Q911
D923
C804
C803
R802
X801
C801
R815
R814
R813
R822
R840
IC801
C812
R841
R842
R843
R812
R811
R810
Q915
R929
R928
R927
R926
R925
R924
C810
Q920
R918
R919
R930
D999
R931
Q914
CNP802
D909
D930
C909
C846
Q921
R920
SW801
JR1
IC902
R817
R818
R819
R824
R809
R808 R807
R806
Q907
Q910
C916
(Page 35)
C843
JR903
Q913
C915
Q906
Q912
R913
R917
C845
33
Q909
C914
33
Q905
C907
D908
D914
Q916
D810
D910
C809
R921
D913
R922
R923
JR929 R912
C905
Note:
• Voltage and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM
<
> : CD PLAY
CDX-L300/L460X
3-13. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 24 for Circuit Boards Location.
D567
8
D574
9
D573
10
D572
11
D571
12
D575
R562
R561
R560
R559
R566
R565
R578
LED502
R571
R580
R570
R564
R577
R563
D562
LED504
LED501
14
D579
D578
D580
D576
LED503
D581
D577
D566
D
13
R582
R574
R573
D568
7
R568
R579
6
D564
D561
D565
C
5
D569
R567
D570
R569
B
4
R583
R575
R576
A
3
R581
2
R572
1
D563
S501
E
S513
R552
R519
S521
R509
S520
R518
S519
S518
R516
R506
R505
R508
R517
S517
S508
S506
R507
S504
R502
JR501 C553
R515
R504
C555
R514
S516
R503
C552
R586
R510
JR505
S510
S509
R587
1
D553
G
S503
55
D554
R588
S515
R553
D552
D551
IC
R501
S511
S505
LCD501
R551
S512
CNP551
JR504
C551
S502
R511
F
R512
R513
S514
JR503
S507
S581
H
(Page 31)
• Semiconductor Location
Ref. No.
D551
D552
D553
D554
D561
D562
D563
D564
34
34
Location
F-5
F-4
G-4
G-5
B-1
C-1
D-1
B-3
Ref. No.
D565
D566
D567
D568
D569
D570
D571
D572
Location
C-3
C-3
A-6
A-5
A-3
A-2
A-10
A-9
Ref. No.
D573
D574
D575
D576
D577
D578
D579
D580
Location
A-8
A-7
B-12
C-12
C-12
A-11
A-12
B-13
Ref. No.
D581
Location
C-13
IC551
G-7
LED501
LED502
LED503
LED504
B-4
C-4
C-11
B-11
CDX-L300/L460X
3-14. SCHEMATIC DIAGRAM — DISPLAY SECTION —
R552
R553
D551
C552
C551
D552
CNP551
D561
LED501
CNP553
D564
D568
D573
D565
D569
D574
D579
D575
C555
R551
C553
D572
LED503
JR505
D576
D571
D580
D562
R586
R587
R588
D570
D563
R559
R560 R561
R562
R565
JR501
R566
D567
R578
D578
R571
R572
R581
R573 R574
R582
(Page 33)
D577
D566
LED502
LED504
D554
D581
R579
R563
D553
R564
R577
R567
R570
R568
R575 R576
R580
R583
R569
S581
S512
S501
R511
R512
R513
R514
R515
R516
R517
S513
S514
S515
S516
S517
S518
S519
R504
R505
R506
R507
R508
R509
S504
S505
S506
S507
S508
S509
R501
R502
S511
S502
R503
S503
R518
S520
R519
S521
R510
S510
JR503
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
35
35
CDX-L300/L460X
• IC Block Diagrams
SD
TD
FD
AGND
ATEST
TEST1
TEST0
DGND
TSTB
TSCK
TSI
TSO
PACK
DVDD
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
MICROCOMPUTER INTERFACE
COMPARATOR
CD-TEXT DECODER
D/A
IN1
5
IN2
6
RF
AMP BLOCK
SVCRAM
POWVCC12
(CH1.CH2)
42 RFCK
TIMING GENERATOR
ROM
DECODER
SVROM
40 DVDD
EFM
TEO 93
FEO
TEC 95
MIRENV
DE-EMPHASIS CIRCUIT
TRACKING
REGISTER
FOCUS
REGISTER
TEO
AGND 96
OCTUPLED
OVERSAMPLING DIGITAL FILTER
COMPARATOR
PD 97
NOISE SHAVER
21 MUTE
19 GND
VO2– 11
36 TX
VO2+ 12
10k
10k
–
VO1– 13
10k
10k
10k
10k
10k
–
VO1+ 14
LEVEL
SHIFT
–
10k
10k
10k
10k
18 VO3–
17 VO3+
10k
–
LEVEL
SHIFT
33 LRCKIN
32 SCKO
LEVEL
SHIFT
–
10k
34 LRCK
–
LEVEL
SHIFT
+
MIRR
TE2 94
RFENV
37 DGND
35 HOLD/WDCK
OUTPUT PROCESSOR
A3T
D/A
INTERFACE
CIRCUIT
CH1-4
MUTE
10k
+
A/D CONVERTER
FOK
TE- 92
+
VOL+ 10
+
DIGITAL
AUDIO
INTERFACE
DEFECT
COMPARATOR
DEFECT
+
POWVCC34
(CH3,CH4)
+
FE- 90
9
38 C16M
SWITCH
FEO 91
VOL–
22 OPOUT3
20 POWVCC
39 TSOI
CLV
PROCESSOR
REFOUT 89
8
+
41 LOCK
F 86
AVDD 88
POWVCC
+
–
MULTIPLIER
B 84
E 87
7
43 MIRR/WFCK
SVDRAM
TEOFS
D 85
PREVCC
44 PLCK
–
C 83
DIGITAL PLL
EFM DEMODULATOR
24 OPIN3+
23 OPIN3–
–
–
ADDER
FEOFS
25 OPOUT4
PREVCC
(PRE.LOADING)
45 DGND
A 82
POWER
SAVE
47 C1D2
46 C1D1
AGND 81
4
48 C2D1
16k
RF- 80
FD/TD/SD/MD
CONTROLLER
PS
X3
10k
+
AUTO GAIN
CONTROLLER
SUB-CODE PROCESSOR
16K
SRAM
MEMORY
PROCESSOR
3
+
EQ1 79
LDCONT
+
EFM
49 C2D2
27 OPIN4+
26 OPIN4–
–
16 VO4–
15 VO4+
–
EQ2 78
50 C2D3
LOADING PRE
FWD REV
–
RFO 77
ERROR
CORRECTION
PROCESSOR
EFM
2
+
AGCI 76
REV
+
MD
67
+
7F DAC0
68
16k
7C DAC1
69
16k
7D DAC2
70
7.5k
7E DAC3
71
7.5k
AVDD
72
7.5k
EFM
73
28 BIAS
–
ASY
74
1
16k
C3T
75
FWD
7.5k
RFI
IC2 BA5810FP-E2 (MG-393X-121//K)
IC2 BA5810FP-E2 (MG-393XA-121//K)
AGCO
IC1 µPD63711GC-8EU (MG-393X-121//K)
IC1 µPD63711GC-8EU (MG-393XA-121//K)
10k
31 SCKIN
30 DOUT
29 DIN
NOISE SHAVER
LD 98
28 FLAG
OUTPUT BUFFER OUTPUT BUFFER
27 EMPH
25
XO
1
OSC
2
OSCILLATOR
BUFFER
24 XI
23 A-GND
22 REG
REGULATOR
ON/OFF
21 VCC
VCC
REF
REFERENCE
DIVIDER
SEEK/RECP
20 AM_CP
+
–
CE
D_IN
CK
D_OUT
3
4
5
6
SERIAL
INTERFACE
SEEK/RECP
18 FM_CP
17 D-GND
18BIT
12BIT
PROGRAMMABLE
COUNTER
18BIT
19 VT
+
PHASE
COMPARATOR
+
40BIT SHIFT
REGISTER
SIG
24
XGND
23
XTAL
22
XVDD
21
L+
20
L–
19
R–
18
R+
17
DAVDD
16
IC601 TB2118F (EL-S)
26 DVDD
OSC
LOUT
15
DAGND
14
REGC
13
DAGND
12
ROUT
11
DAVDD
10
DVDD
9
XTALEN
8
SI
7
SO
6
SCK
5
STB
4
A0
3
RST
2
RFOK
DGND
1
SCF
XTAL
MICROCOMPUTER INTERFACE
–
PN 99
AVDD 100
PRESCALLER
4BIT SWALLOW
COUNTER
+
SR
7
LCL
8
I/O-2
9
SEEK 10
MONO 11
VDD2 12
36
36
AMP
AMP
I/O
PORT
VDD2
15 FM_VCO
VDD
22BIT
OUTPUT
PORT
20BIT
IF COUNTER
AMP
16 AM_VCO
14 VDD
13 IFC
CDX-L300/L460X
IC401 LC75421M-TLM-E
36 CL
2
35 VDD
VSS
3
LROUT
4
34 RROUT
LFOUT
5
33 RFOUT
–
+
–
+
–
1
–
DI
CE
+
+
CCB
INTERFACE
7
32 RFIN
31 ROUT
+
–
–
6
+
LFIN
LOUT
8
30 RSB
LBASS2
9
29 RBASS2
LOGIC
CIRCUIT
CONTROL
CIRCUIT
CONTROL
CIRCUIT
+
+
–
–
LSB
28 RBASS1
+
+
LVREF
–
–
LBASS1 10
RVREF
27 RTRE
LTRE 11
–
–
LIN 12
26 RIN
+
+
LSELO 13
25 RSELO
L5
14
24 R5
L4
15
23 R4
L3
16
22 R3
L2
17
18
–
+
+
L1
21 R2
–
20 R1
19 VREF
37
CDX-L300/L460X
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories and hardware (# mark) list are
given in the last of this parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. CHASSIS SECTION
MG-393X-121//K
MG-393XA-121//K
3
5
#1
4
#2
#2
6
#2
#3
10
11
2
#2
#2
#2
9
7
8
TU601
F901
12
6
#1
#1
#1
1
Ref. No.
Part No.
Description
* 1
2
3
* 4
* 5
3-224-612-11
3-224-309-21
1-776-206-21
3-024-285-01
3-041-173-11
CHASSIS (CD)
COVER
CORD (WITH CONNECTOR) (POWER)
CUSHION (RUBBER)
BRACKET (CD)
6
7
7
38
3-922-535-11 SCREW (+BTT)
A-3283-234-A MAIN BOARD, COMPLETE (L460X)
A-3283-238-A MAIN BOARD, COMPLETE (L300)
Remark
Ref. No.
Part No.
Description
* 8
* 9
10
11
* 12
3-224-613-01
3-019-565-01
1-683-602-11
3-041-261-11
3-048-259-01
HEAT SINK
BRACKET (IC)
SPEAKER BOARD
BRACKET (TR)
SHEET (E)
F901
TU601
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
A-3220-835-A TUNER UNIT (TUX-010)
Remark
CDX-L300/L460X
4-2. FRONT PANEL SECTION
#4
60
61
59
63
#4
LCD501
64
62
65
57
58
56
55
53
54
52
Ref. No.
51
Part No.
Description
Ref. No.
Part No.
Description
51
51
52
53
53
X-3381-455-1
X-3381-476-1
3-224-605-01
3-224-604-01
3-224-604-11
PANEL SUB ASSY, FRONT (L460X)
PANEL SUB ASSY, FRONT (L300)
BUTTON (SEEK/AMS)
BUTTON (+/–) (L300)
BUTTON (+/–) (L460X)
Remark
* 58
59
60
61
62
3-224-609-02
3-224-610-11
X-3381-070-1
A-3283-240-A
3-224-617-01
PLATE (LCD), GROUND
SHEET (LCD), DIFFUSION
HOLDER (LCD) ASSY
DISPLAY BOARD, COMPLETE
BUTTON (RESET)
Remark
54
55
56
57
3-224-601-01
3-224-603-01
3-224-600-01
3-224-602-01
BUTTON (EJECT)
BUTTON (OFF)
BUTTON (1-6)
BUTTON (SOURCE)
* 63
* 64
65
LCD501
3-227-293-01
3-229-751-01
1-765-143-41
1-804-300-21
SHEET (LCD)
SHEET (LCD.UP)
WIRE (FLAT TYPE) (10 CORE) (CNP553)
DISPLAY PANEL, LIQUID CRYSTAL
39
CDX-L300/L460X
4-3. CD MECHANISM SECTION (1)
(MG-393X-121//K)
102
#8
#8
104
103
107
109
101
116
115
114
106
114
105
105
C
113
M903
111
C
110
#6
112
#7
#7
108
Ref. No.
Part No.
Description
* 101
102
103
104
105
1-676-709-11
3-040-039-01
3-040-038-01
3-040-050-01
3-040-022-01
IN SELF SW BOARD
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (ROLLER), SHAFT
106
107
108
109
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
40
Remark
#8
Ref. No.
Part No.
Description
110
* 111
112
113
114
3-040-040-01
A-3283-212-A
3-221-779-01
3-040-034-01
3-040-042-01
ARM (ROLLER)
SERVO BOARD, COMPLETE
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
115
116
M903
3-043-880-01 RING (RA), RETAINING
3-044-206-11 SCREW, SPECIAL
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
Remark
CDX-L300/L460X
4-4. CD MECHANISM SECTION (2)
(MG-393X-121//K)
154
151
156
157
157
158
D
164
160
not supplied
162
153
155
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-01
3-040-031-01
3-040-056-01
3-040-024-01
3-040-054-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WHEEL (LW), WORM
156
157
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
Remark
Ref. No.
Part No.
Description
158
159
160
161
162
3-040-033-01
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
SPRING (KF1), TENSION
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
163
164
3-040-052-01 WHEEL (U), WORM
3-040-051-01 LEVER (TR)
Remark
41
CDX-L300/L460X
4-5. CD MECHANISM SECTION (3)
(MG-393X-121//K)
201
M901
207
202
M902
203
208
#5
209
210
#8
204
205
211
206
#9
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
205
X-3378-480-1
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
CHASSIS (OP) ASSY (including M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
SHAFT (FEED) ASSY
206
3-040-030-01 SPRING (FEED), PLATE
42
Remark
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
207
* 208
209
0 210
211
1-677-182-11
1-676-708-11
3-909-607-01
8-820-103-11
1-676-707-11
MOTOR FLEXIBLE BOARD
SL SW BOARD
SCREW
PICK-UP, OPTICAL KSS-720A/C-RP
PICK-UP FLEXIBLE BOARD
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
Remark
CDX-L300/L460X
4-6. CD MECHANISM SECTION (1)
(MG-393XA-121//K)
102
#8
#8
104
103
107
109
101
116
115
114
106
114
105
111
105
C
117
113
C
110
#6
M903
112
#7
#7
108
Ref. No.
Part No.
Description
101
102
103
104
105
1-683-283-11
3-040-039-02
3-040-038-01
3-040-050-01
3-040-022-01
IN SELF SW BOARD
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (ROLLER), SHAFT
106
107
108
109
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
Remark
Ref. No.
#8
Part No.
Description
110
111
112
113
114
3-040-040-02
A-3283-233-A
3-221-779-01
3-040-034-01
3-040-042-01
ARM (ROLLER)
SERVO BOARD, COMPLETE
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
115
116
117
M903
3-043-880-01
3-044-206-11
1-683-284-11
A-3315-039-A
RING (RA), RETAINING
SCREW, SPECIAL
FLEXIBLE BOARD
MOTOR SUB ASSY, LO (LOADING)
Remark
43
CDX-L300/L460X
4-7. CD MECHANISM SECTION (2)
(MG-393XA-121//K)
154
151
156
157
157
158
D
164
160
not supplied
162
153
155
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-01
3-040-031-01
3-040-056-01
3-040-024-01
3-040-054-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WHEEL (LW), WORM
156
157
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
44
Remark
Ref. No.
Part No.
Description
158
159
160
161
162
3-040-033-01
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
SPRING (KF1), TENSION
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
163
164
3-040-052-01 WHEEL (U), WORM
3-040-051-02 LEVER (TR)
Remark
CDX-L300/L460X
4-8. CD MECHANISM SECTION (3)
(MG-393XA-121//K)
201
M901
207
202
M902
203
208
#5
209
210
#8
204
205
206
#9
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
205
X-3378-480-1
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
CHASSIS (OP) ASSY (including M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
SHAFT (FEED) ASSY
206
3-040-030-01 SPRING (FEED), PLATE
Remark
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
207
208
209
0 210
M902
1-823-641-11
1-683-282-11
3-909-607-01
8-820-103-11
A-3301-985-A
CABLE, FLEXIBLE FLAT (6 CORE)
SL SW BOARD
SCREW
PICK-UP, OPTICAL KSS-720A/C-RP
MOTOR ASSY, SLED (SLED)
Remark
45
CDX-L300/L460X
SECTION 5
ELECTRICAL PARTS LIST
DISPLAY
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Abbreviation
CND : Canadian model
393X : MG-393X-121//K
393XA: MG-393XA-121//K
Ref. No.
Part No.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
Description
Remark
Ref. No.
Part No.
*
*
Description
Remark
< IC >
IC551
*
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
A-3283-240-A DISPLAY BOARD, COMPLETE
************************
1-765-143-41
3-224-609-02
3-224-610-11
3-227-293-01
3-229-751-01
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
WIRE (FLAT TYPE) (10 CORE) (CNP553)
PLATE (LCD), GROUND
SHEET (LCD), DIFFUSION
SHEET (LCD)
SHEET (LCD.UP)
8-759-369-90 IC LC75822ED
< JUMPER RESISTOR >
JR501
JR503
JR505
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
0
5%
5%
5%
1/16W
1/16W
1/16W
< CAPACITOR >
< LIQUID CRYSTAL DISPLAY >
C551
C552
C553
C555
1-164-315-11
1-164-156-11
1-162-927-11
1-119-866-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
100PF
0.68uF
5%
5%
10%
50V
25V
50V
10V
< CONNECTOR >
* CNP551 1-779-130-11 PIN, CONNECTOR 1P
LCD501 1-804-300-21 DISPLAY PANEL, LIQUID CRYSTAL
< DIODE >
LED501
LED502
LED503
LED504
8-719-072-40
8-719-072-40
8-719-072-40
8-719-072-40
LED
LED
LED
LED
LBA676-J2K1K2 (LCD BACK LIGHT)
LBA676-J2K1K2 (LCD BACK LIGHT)
LBA676-J2K1K2 (LCD BACK LIGHT)
LBA676-J2K1K2 (LCD BACK LIGHT)
< DIODE >
< RESISTOR >
D551
D552
D553
D554
D561
8-719-073-15
8-719-988-61
8-719-067-70
8-719-068-68
8-719-053-09
DIODE SDZ5V1
DIODE 1SS355TE-17
DIODE SDZ6V2
DIODE SDZ6V2WA
LED SML-310VTT86 (SEEK/AMS m . –)
D562
D563
D564
D565
D566
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VTT86 (SEEK/AMS + > M)
SML-310VTT86 (Z)
SML-310VTT86 (OFF)
SML-310VTT86 (D-BASS)
SML-310VTT86 (MBP)
D567
D568
D569
D570
D571
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VTT86 (5)
SML-310VTT86 (6)
SML-310VTT86 (BTM)
SML-310VTT86 (DSPL)
SML-310VTT86 (1)
D572
D573
D574
D575
D576
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VTT86 (2)
SML-310VTT86 (3/REP)
SML-310VTT86 (4/SHUF)
SML-310VTT86 (SEL)
SML-310VTT86 (MODE)
D577
D578
D579
D580
D581
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VTT86 (SRC – SOURCE)
SML-310VTT86 (SENS)
SML-310VTT86 (ATT)
SML-310VTT86 (VOLUME –)
SML-310VTT86 (VOLUME +)
46
R501
R502
R503
R504
R505
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
1K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R506
R507
R508
R509
R510
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
1-218-867-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R511
R512
R513
R514
R515
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
1K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R516
R517
R518
R519
R551
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
1-218-331-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
2.2K
3.3K
4.7K
51K
2%
2%
2%
2%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R552
R553
R559
R560
R561
1-216-819-11
1-216-857-11
1-216-818-11
1-216-818-11
1-216-818-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
1M
560
560
560
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
CDX-L300/L460X
DISPLAY
Ref. No.
IN SELF SW
MAIN
Part No.
Description
Remark
Ref. No.
Part No.
R562
R563
R564
R565
R566
1-216-818-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
560
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
*
1-676-709-11 IN SELF SW BOARD (393X)
1-683-283-11 IN SELF SW BOARD (393XA)
****************
R567
R568
R569
R570
R571
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
SW2
1-529-566-31 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-31 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
R572
R573
R574
R575
R576
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R577
R578
R579
R580
R581
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R582
R583
R586
R587
R588
1-216-821-11
1-216-821-11
1-218-847-11
1-218-847-11
1-218-847-11
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
1K
1K
1K
5%
5%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
< SWITCH >
S501
S502
S503
S504
S505
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (Z)
SWITCH, KEYBOARD (SRC – SOURCE)
SWITCH, KEYBOARD (MODE)
SWITCH, KEYBOARD (SEL)
SWITCH, KEYBOARD (VOLUME +)
S506
S507
S508
S509
S510
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (VOLUME –)
SWITCH, KEYBOARD (ATT)
SWITCH, KEYBOARD (SENS)
SWITCH, KEYBOARD (BTM)
SWITCH, KEYBOARD (DSPL)
S511
S512
S513
S514
S515
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (OFF)
SWITCH, KEYBOARD (D-BASS)
SWITCH, KEYBOARD (MBP)
SWITCH, KEYBOARD (SEEK/AMS + > M)
SWITCH, KEYBOARD (SEEK/AMS m . –)
S516
S517
S518
S519
S520
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (6)
SWITCH, KEYBOARD (5)
SWITCH, KEYBOARD (4/SHUF)
SWITCH, KEYBOARD (3/REP)
SWITCH, KEYBOARD (2)
S521
1-572-704-31 SWITCH, KEYBOARD (1)
S581
1-572-704-31 SWITCH, KEYBOARD (RESET)
*************************************************************
Description
Remark
< SWITCH >
A-3283-234-A MAIN BOARD, COMPLETE
(including SPEAKER BOARD) (L460X)
A-3283-238-A MAIN BOARD, COMPLETE
(including SPEAKER BOARD) (L300)
*********************
3-019-565-01
3-041-261-11
3-224-613-01
7-685-793-09
7-685-795-09
*
*
BRACKET (IC)
BRACKET (TR)
HEAT SINK
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
< CAPACITOR >
C101
C102
C103
C104
C105
1-164-346-11
1-164-346-11
1-104-396-11
1-104-396-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
10uF
10uF
0.001uF
20%
20%
10%
16V
16V
16V
16V
50V
C108
C110
C111
C113
C114
1-164-346-11
1-164-156-11
1-164-156-11
1-164-677-11
1-124-257-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.1uF
0.1uF
0.033uF
2.2uF
10%
20%
16V
25V
25V
16V
50V
C115
C116
C117
C118
C119
1-162-965-11
1-164-346-11
1-164-346-11
1-164-346-11
1-164-346-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF 10%
1uF
1uF
1uF
1uF
50V
16V
16V
16V
16V
C201
C202
C203
C204
C205
1-164-346-11
1-164-346-11
1-104-396-11
1-104-396-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
10uF
10uF
0.001uF
20%
20%
10%
16V
16V
16V
16V
50V
C208
C210
C211
C213
C214
1-164-346-11
1-164-156-11
1-164-156-11
1-164-677-11
1-124-257-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.1uF
0.1uF
0.033uF
2.2uF
10%
20%
16V
25V
25V
16V
50V
C215
C216
C217
C218
C219
1-162-965-11
1-164-346-11
1-164-346-11
1-164-346-11
1-124-234-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.0015uF 10%
1uF
1uF
1uF
22uF
20%
50V
16V
16V
16V
16V
C401
C407
C426
1-126-163-11 ELECT
1-104-396-11 ELECT
1-162-964-11 CERAMIC CHIP
4.7uF
10uF
0.001uF
50V
16V
50V
20%
20%
10%
47
CDX-L300/L460X
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C432
C435
C603
C604
C605
1-124-589-11
1-124-589-11
1-164-227-11
1-162-970-11
1-104-665-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
47uF
47uF
0.022uF
0.01uF
100uF
20%
20%
10%
10%
20%
16V
16V
25V
25V
10V
Remark
Ref. No.
C849
C901
C902
C904
C905
1-162-964-11
1-126-936-11
1-164-156-11
1-126-160-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.001uF
3300uF
0.1uF
1uF
0.1uF
Remark
C606
C608
C609
C610
C611
1-104-665-11
1-164-156-11
1-162-970-11
1-104-396-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
0.1uF
0.01uF
10uF
100PF
20%
10%
20%
5%
10V
25V
25V
16V
50V
C907
C909
C914
C915
C916
1-164-156-11
1-164-156-11
1-104-665-11
1-110-654-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
DOUBLE LAYERS
CERAMIC CHIP
0.1uF
0.1uF
100uF
0.047F
0.1uF
20%
25V
25V
10V
5.5V
25V
C612
C613
C614
C615
C617
1-162-927-11
1-162-927-11
1-164-174-11
1-165-176-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.0082uF
0.047uF
0.047uF
5%
5%
10%
10%
10%
50V
50V
25V
16V
16V
C919
1-124-229-00 ELECT
33uF
20%
10V
C618
C619
C620
C621
C622
1-162-964-11
1-162-964-11
1-104-665-11
1-104-396-11
1-162-911-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.001uF
0.001uF
100uF
10uF
6PF
10%
10%
20%
20%
0.5PF
50V
50V
10V
16V
50V
C623
C624
C625
C626
C627
1-162-912-11
1-162-915-11
1-162-963-11
1-164-315-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
7PF
10PF
680PF
470PF
0.1uF
0.5PF
0.5PF
10%
5%
50V
50V
50V
50V
25V
C631
C633
C635
C650
C651
1-104-396-11
1-162-964-11
1-162-966-11
1-164-245-11
1-164-245-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.001uF
0.0022uF
0.015uF
0.015uF
20%
10%
10%
10%
10%
16V
50V
50V
25V
25V
C666
C701
C702
C703
C704
1-162-919-11
1-124-584-00
1-124-584-00
1-124-584-00
1-124-584-00
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
22PF
100uF
100uF
100uF
100uF
5%
20%
20%
20%
20%
50V
10V
10V
10V
10V
C706
C707
C801
C802
C803
1-162-964-11
1-162-964-11
1-104-396-11
1-164-156-11
1-162-918-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
10uF
0.1uF
18PF
10%
10%
20%
50V
50V
16V
25V
50V
C804
C806
C809
C810
C812
1-164-160-11
1-162-910-11
1-164-156-11
1-162-964-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20PF
5PF
0.1uF
0.001uF
0.01uF
5%
50V
0.25PF 50V
25V
10%
50V
10%
25V
C841
C842
C843
C844
C845
1-162-964-11
1-162-964-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
25V
25V
25V
C846
C847
C848
1-162-964-11 CERAMIC CHIP
1-164-346-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
0.001uF
1uF
0.001uF
10%
50V
16V
50V
48
10%
20%
50V
16V
25V
50V
25V
< JACK >
CNJ601 1-793-598-11 JACK (ANTENNA)
< CONNECTOR >
CNP501
CNP701
CNP701
CNP802
1-774-701-11
1-764-617-12
1-815-260-11
1-569-853-11
PIN, CONNECTOR 16P
PIN, CONNECTOR (PC BOARD) 30P (393X)
CONNECTOR, BOARD TO BOARD 30P (393XA)
SOCKET, CONNECTOR 10P
< SURGE ABSORBER >
CP601
1-803-335-21 ABSORBER, CHIP SURGE
< DIODE >
5%
10%
20%
D401
D402
D444
D445
D446
8-719-991-33
8-719-991-33
8-719-991-33
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS355TE-17
1SS355TE-17
D604
D666
D810
D901
D903
8-719-109-85
8-719-988-61
8-719-988-61
8-719-049-38
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
RD5.1ES-B2
1SS355TE-17
1SS355TE-17
1N5404TU
RD6.8ES-B2
D904
D906
D907
D908
D909
8-719-200-82
8-719-921-63
8-719-110-49
8-719-921-63
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
MTZJ-7.5B
RD18ES-B2
MTZJ-7.5B
RD6.8ES-B2
D910
D913
D914
D915
D916
8-719-109-89
8-719-110-14
8-719-991-33
8-719-110-49
8-719-110-49
DIODE
DIODE
DIODE
DIODE
DIODE
RD5.6ES-B2
RD9.1ES-B3
1SS133T-77
RD18ES-B2
RD18ES-B2
D917
D918
D919
D920
D921
8-719-110-49
8-719-110-49
8-719-110-49
8-719-074-47
8-719-074-47
DIODE
DIODE
DIODE
DIODE
DIODE
RD18ES-B2
RD18ES-B2
RD18ES-B2
CRS02(TE85L)
CRS02(TE85L)
D922
D923
8-719-110-49 DIODE RD18ES-B2
8-719-110-14 DIODE RD9.1ES-B3
CDX-L300/L460X
MAIN
Ref. No.
D930
D999
Part No.
Description
Remark
8-719-109-89 DIODE RD5.6ES-B2
8-719-991-33 DIODE 1SS133T-77
< IC >
IC101
IC401
IC601
IC801
IC902
8-759-827-12
8-759-827-11
8-759-586-59
6-801-168-01
8-759-837-07
IC
IC
IC
IC
IC
TA8272H
LC75421M-TLM-E
TB2118F-EL-S
uPD780024AGK-B52-9ET
S7139SF
Ref. No.
Part No.
Description
Q911
Q912
Q913
Q914
Q915
8-729-055-96
8-729-055-92
8-729-019-00
8-729-055-96
8-729-049-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
SRA2203SF
2SD2394-G
SRC1203SF
STB1132Y
Remark
Q916
Q917
Q918
Q919
Q920
8-729-055-92
8-729-820-46
8-729-055-92
8-729-052-35
8-729-052-35
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRA2203SF
2SB1202FAS
SRA2203SF
STD1664
STD1664
Q921
Q929
8-729-055-96 TRANSISTOR SRC1203SF
8-729-055-96 TRANSISTOR SRC1203SF
< JUMPER RESISTOR >
JR1
JR101
JR602
JR610
JR901
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
JR903
JR929
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
5%
5%
1/16W
1/16W
< RESISTOR >
R105
R106
R107
R108
R109
1-249-431-11
1-249-431-11
1-216-841-11
1-216-841-11
1-216-809-11
CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
15K
15K
47K
47K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/16W
1/16W
1/16W
R110
R113
R115
R205
R206
1-216-809-11
1-216-831-11
1-216-834-11
1-249-431-11
1-249-431-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
CARBON
100
6.8K
12K
15K
15K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/4W
1/4W
R207
R208
R209
R210
R213
1-216-841-11
1-216-841-11
1-216-809-11
1-216-809-11
1-216-831-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
100
100
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R215
R401
R404
R407
R408
1-216-834-11
1-249-429-11
1-249-417-11
1-216-841-11
1-216-831-11
METAL CHIP
CARBON
CARBON
METAL CHIP
METAL CHIP
12K
10K
1K
47K
6.8K
5%
5%
5%
5%
5%
1/16W
1/4W
1/4W
1/16W
1/16W
R410
R444
R601
R602
R603
1-216-805-11
1-216-864-11
1-249-417-11
1-216-821-11
1-249-407-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
CARBON
47
0
1K
1K
150
5%
5%
5%
5%
5%
1/16W
1/16W
1/4W
1/16W
1/4W
R604
R605
R606
R607
R608
1-216-821-11
1-216-841-11
1-216-841-11
1-216-827-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
47K
3.3K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R609
R610
R611
R612
R613
1-216-809-11
1-216-809-11
1-216-826-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
2.7K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R614
R615
R616
R617
1-216-174-00
1-216-825-11
1-216-845-11
1-216-825-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
2.2K
100K
2.2K
5%
5%
5%
5%
1/8W
1/16W
1/16W
1/16W
< COIL >
JW13
L601
L603
L604
L605
1-410-509-11
1-410-508-11
1-412-006-31
1-410-750-41
1-216-864-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
METAL CHIP
L669
L701
L702
L703
L901
1-424-759-21
1-410-513-11
1-410-513-11
1-410-513-11
1-419-476-31
COIL (AM ANT)
INDUCTOR
INDUCTOR
INDUCTOR
COIL, CHOKE
10uH
8.2uH
10uH
0.47uH
0
5%
22uH
22uH
22uH
250uH
< JACK >
PJ401
1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR)
1/16W
< TRANSISTOR >
Q101
Q102
Q201
Q202
Q401
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
SRA2203SF
Q402
Q603
Q604
Q605
Q606
8-729-055-96
8-729-030-51
8-729-055-96
8-729-030-51
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SA1515S-R-TP
SRC1203SF
2SA1515S-R-TP
SRC1203SF
Q902
Q903
Q904
Q905
Q906
8-729-049-40
8-729-055-96
8-729-055-96
8-729-055-96
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC5343SFG
SRC1203SF
SRC1203SF
SRC1203SF
SRA2203SF
Q907
Q909
Q910
8-729-019-00 TRANSISTOR 2SD2394-G
8-729-055-96 TRANSISTOR SRC1203SF
8-729-052-35 TRANSISTOR STD1664
49
CDX-L300/L460X
MAIN
Ref. No.
SERVO
Part No.
Description
Remark
Part No.
Description
R910
R911
R912
R913
R917
1-216-836-11
1-216-821-11
1-249-413-11
1-249-417-11
1-249-409-11
METAL CHIP
METAL CHIP
CARBON
CARBON
CARBON
18K
1K
470
1K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/4W
1/4W
1/4W
R918
R919
R920
R921
R922
1-216-845-11
1-249-421-11
1-216-849-11
1-216-841-11
1-208-806-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
RES-CHIP
100K
2.2K
220K
47K
10K
5%
5%
5%
5%
0.5%
1/16W
1/4W
1/16W
1/16W
1/10W
R923
R924
R925
R926
R927
1-208-806-11
1-249-404-00
1-249-404-00
1-249-404-00
1-249-404-00
RES-CHIP
CARBON
CARBON
CARBON
CARBON
10K
82
82
82
82
0.5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
1/4W
1/16W
1/16W
1/16W
1/4W
1/16W
R928
R929
R930
R931
R932
1-249-404-00
1-249-404-00
1-249-395-11
1-249-427-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
82
82
15
6.8K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R933
R934
1-216-821-11 METAL CHIP
1-249-409-11 CARBON
1K
220
5%
5%
1/16W
1/4W
220K
1K
1K
1K
22K
5%
5%
5%
5%
5%
1/16W
1/4W
1/16W
1/16W
1/16W
CARBON
CARBON
CARBON
METAL CHIP
METAL CHIP
100
100
100
22K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/16W
1/16W
R815
R817
1-216-809-11 METAL CHIP
1-216-841-11 METAL CHIP
100
47K
5%
5%
R818
1-216-845-11 METAL CHIP
100K
5%
R819
1-216-864-11 METAL CHIP
0
5%
R822
1-249-441-11 CARBON
100K
5%
1/16W
1/16W
(L460X)
1/16W
(L460X)
1/16W
(L300)
1/4W
R824
R840
R841
R842
R843
1-216-849-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C1
C3
C4
C5
C6
1-164-227-11
1-164-227-11
1-104-609-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
100uF
0.022uF
0.022uF
10%
10%
20%
10%
10%
25V
25V
4V
25V
25V
R901
R906
R907
R908
R909
1-216-214-00
1-249-417-11
1-216-841-11
1-216-841-11
1-216-828-11
RES-CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
47K
47K
3.9K
5%
5%
5%
5%
5%
1/8W
1/4W
1/16W
1/16W
1/16W
C8
C9
C10
C11
C13
1-107-826-11
1-162-924-11
1-162-924-11
1-162-909-11
1-162-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
56PF
56PF
4PF
12PF
10%
5%
5%
0.25PF
5%
16V
50V
50V
50V
50V
R618
R619
R620
1-216-845-11 METAL CHIP
1-216-817-11 METAL CHIP
1-216-817-11 METAL CHIP
100K
470
470
5%
5%
5%
R620
1-216-821-11 METAL CHIP
1K
5%
R621
1-216-835-11 METAL CHIP
15K
5%
R622
1-216-817-11 METAL CHIP
470
5%
R622
1-216-821-11 METAL CHIP
1K
5%
R623
R628
1-216-835-11 METAL CHIP
1-216-829-11 METAL CHIP
15K
4.7K
5%
5%
R628
1-216-830-11 METAL CHIP
5.6K
5%
R704
R705
R706
R707
R708
1-216-821-11
1-216-821-11
1-216-864-11
1-247-887-00
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
1K
1K
0
220K
1K
5%
5%
5%
5%
5%
R709
R710
R711
R714
R716
1-216-821-11
1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
2.2K
2.2K
R802
R806
R807
R808
R809
1-216-849-11
1-249-417-11
1-216-821-11
1-216-821-11
1-216-837-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
R810
R811
R812
R813
R814
1-247-807-31
1-247-807-31
1-247-807-31
1-216-837-11
1-216-809-11
Ref. No.
1/16W
1/16W
1/16W
(L300)
1/16W
(L460X)
1/16W
1/16W
(L300)
1/16W
(L460X)
1/16W
1/16W
(L300)
1/16W
(L460X)
Remark
< SWITCH >
SW801
1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT) (L460X)
< THERMISTOR >
TH901
1-809-148-11 THERMISTOR PTH8L07AR2R0M1B510
< TUNER >
50
TU601
A-3220-835-A TUNER UNIT (TUX-010)
< VIBRATOR >
X601
1-781-246-21 VIBRATOR, CRYSTAL (10.25MHz)
X801
1-795-259-11 VIBRATOR, CERAMIC (8.38MHz)
X802
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
A-3283-212-A SERVO BOARD, COMPLETE (393X)
**********************
*
< CAPACITOR >
CDX-L300/L460X
SERVO
Ref. No.
Part No.
Description
Part No.
Description
C14
C15
C16
C17
C18
1-125-837-00
1-164-227-11
1-164-227-11
1-162-970-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.022uF
0.022uF
0.01uF
0.0022uF
10%
10%
10%
10%
10%
6.3V
25V
25V
25V
50V
Remark
Ref. No.
R8
R9
R10
R12
R14
1-216-833-11
1-216-840-11
1-216-835-11
1-216-837-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
39K
15K
22K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C19
C20
C21
C22
C23
1-107-826-11
1-107-826-11
1-164-227-11
1-164-227-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.022uF
0.022uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
25V
25V
25V
R15
R17
R18
R19
R20
1-216-841-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C24
C25
C26
C27
C29
1-164-227-11
1-164-227-11
1-126-391-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
47uF
0.022uF
0.022uF
10%
10%
20%
10%
10%
25V
25V
6.3V
25V
25V
R21
R22
R24
R25
R26
1-216-821-11
1-216-821-11
1-216-864-11
1-216-864-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
0
0
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C30
C34
C35
C36
C37
1-164-227-11
1-164-227-11
1-164-227-11
1-164-227-11
1-126-393-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.022uF
0.022uF
0.022uF
0.022uF
33uF
10%
10%
10%
10%
20%
25V
25V
25V
25V
10V
R29
R30
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
5%
5%
1/16W
1/16W
C38
C40
C41
C43
C44
1-164-227-11
1-107-826-11
1-164-227-11
1-162-967-11
1-125-837-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.1uF
0.022uF
0.0033uF
1uF
10%
10%
10%
10%
10%
25V
16V
25V
50V
6.3V
C45
1-164-227-11 CERAMIC CHIP
0.022uF
10%
25V
< SWITCH >
SW1
X1
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE)
(16.9344MHz)
*************************************************************
A-3283-233-A SERVO BOARD, COMPLETE (393XA)
**********************
1-683-284-11 FLEXIBLE BOARD
1-764-616-12 CONNECTOR, BOARD TO BOARD 30P
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-770-347-21 CONNECTOR, FPC 6P
< CAPACITOR >
< JUMPER RESISTOR >
FB1
FB2
FB3
FB4
FB6
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
FB7
1-216-864-11 METAL CHIP
0
5%
1/16W
< IC >
IC1
IC2
8-759-699-98 IC uPD63711GC-8EU
8-759-658-87 IC BA5810FP-E2
< TRANSISTOR >
Q1
C1
C3
C4
C5
C6
1-162-970-11
1-162-970-11
1-104-609-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100uF
0.01uF
0.01uF
10%
10%
20%
10%
10%
25V
25V
4V
25V
25V
C8
C9
C10
C11
C13
1-107-826-11
1-162-924-11
1-162-924-11
1-162-909-11
1-162-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
56PF
56PF
4PF
12PF
10%
5%
5%
0.25PF
5%
16V
50V
50V
50V
50V
C14
C15
C16
C17
C18
1-125-837-00
1-162-970-11
1-162-970-11
1-162-970-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
0.01uF
0.01uF
0.0022uF
10%
10%
10%
10%
10%
6.3V
25V
25V
25V
50V
C19
C20
C21
C22
C23
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
25V
25V
25V
C24
1-162-970-11 CERAMIC CHIP
0.01uF
10%
25V
8-729-904-87 TRANSISTOR 2SB1197K-R
< RESISTOR >
R3
R5
R6
R7
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)
< VIBRATOR >
< CONNECTOR >
CN1
CN2
CN3
Remark
1-216-797-11
1-218-344-11
1-216-837-11
1-216-839-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
10
7.5K
22K
33K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
51
CDX-L300/L460X
SERVO
Ref. No.
SL SW
SPEAKER
Part No.
Description
C25
C26
C27
C29
C30
1-162-970-11
1-126-391-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
4.7uF
0.01uF
0.01uF
0.01uF
10%
20%
10%
10%
10%
25V
6.3V
25V
25V
25V
Remark
C34
C35
C36
C37
C38
1-162-970-11
1-164-227-11
1-162-970-11
1-126-393-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
0.022uF
0.01uF
33uF
0.01uF
10%
10%
10%
20%
10%
25V
25V
25V
10V
25V
C40
C41
C43
C44
C45
1-107-826-11
1-162-970-11
1-162-967-11
1-125-837-00
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.0033uF
1uF
0.01uF
10%
10%
10%
10%
10%
16V
25V
50V
6.3V
25V
Ref. No.
R24
R25
R26
R29
R30
Part No.
Description
1-216-864-11
1-216-864-11
1-216-797-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
Remark
0
0
10
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< SWITCH >
SW1
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)
< VIBRATOR >
X1
1-795-520-11 VIBRATOR, CERAMIC (16.9344MHz)
*************************************************************
1-676-708-11 SL SW BOARD (393X)
1-683-282-11 SL SW BOARD (393XA)
************
*
< CONNECTOR >
< SWITCH >
CN1
CN3
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P
1-816-275-11 FFC/FPC CONNECTOR 6P
SW4
1-529-565-41 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
< JUMPER RESISTOR >
FB1
FB2
FB3
FB4
FB6
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
FB7
1-216-864-11 METAL CHIP
0
5%
1/16W
8-759-699-98 IC uPD63711GC-8EU
8-759-658-87 IC BA5810FP-E2
1-776-206-21
1-683-284-11
X-3378-480-1
1-677-182-11
1-823-641-11
CORD (WITH CONNECTOR) (POWER)
FLEXIBLE BOARD (393XA)
CHASSIS (OP) ASSY (including M901)
MOTOR FLEXIBLE BOARD (393X)
CABLE, FLEXIBLE FLAT (6 CORE) (393XA)
0 210
8-820-103-11 PICK-UP, OPTICAL KSS-720A/C-RP
211
1-676-707-11 PICK-UP FLEXIBLE BOARD (393X)
F901
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
M903
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
*************************************************************
< TRANSISTOR >
Q1
MISCELLANEOUS
***************
3
117
201
207
207
< IC >
IC1
IC2
1-683-602-11 SPEAKER BOARD (supplied with
MAIN BOARD, COMPLETE)
**************
*************************************************************
8-729-904-87 TRANSISTOR 2SB1197K-R
< RESISTOR >
R3
R5
R6
R7
R8
1-216-797-11
1-218-344-11
1-216-837-11
1-216-839-11
1-216-833-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
7.5K
22K
33K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R9
R10
R12
R14
R15
1-216-840-11
1-216-835-11
1-216-837-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
39K
15K
22K
47K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R17
R18
R19
R20
R21
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R22
1-216-821-11 METAL CHIP
1K
5%
1/16W
ACCESSORIES
************
3-237-523-11 MANUAL, INSTRUCTION (ENGLISH,
TRADITIONAL CHINESE) (L460X)
3-237-524-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
TRADITIONAL CHINESE) (L460X)
3-237-525-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH) (L300)
3-237-526-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
(L300)
*************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
52
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
CDX-L300/L460X
Ref. No.
Part No.
Description
Remark
**************
HARDWARE LIST
**************
#1
#2
#3
#4
#5
7-685-792-09
7-685-793-09
7-685-795-09
7-685-105-19
7-627-850-28
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
SCREW +P 2X8 TYPE2 NON-SLIT
SCREW, PRECISION +P 1.4X3
#6
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3
#7
7-628-253-00 SCREW, SPECIAL
#8
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3
#9
7-685-780-01 SCREW +PTT 2X3 (S)
*************************************************************
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
251
252
253
254
255
256
* 257
251
3-014-370-21
X-3366-405-1
3-934-325-01
3-030-929-04
3-224-614-01
FRAME, FITTING
SCREW ASSY (EXP), FITTING (L460X)
SCREW (+K 5X8 TP)
SPRING, FITTING
COLLAR
1-776-206-21 CORD (WITH CONNECTOR) (POWER)
3-035-161-01 BRACKET (RELEASE)
252
253
254
256
257
255
53
CDX-L300/L460X
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
54
Date
2001. 11
Description of Revision
New