Download Sony 2008H05-1 Car Stereo System User Manual

SCD-XA5400ES
SERVICE MANUAL
US Model
Canadian Model
AEP Model
Ver. 1.0 2008.08
Model Name Using Similar Mechanism
NEW
Mechanism Type
CDM66F-DVBU101
Optical Pick-up Block Name
KHM-313CAB
SPECIFICATIONS
When a Super Audio CD is played
General
Output jacks
Playing frequency range 2 Hz to 100 kHz
Frequency response
2 Hz to 50 kHz (–3 dB)
Dynamic range
110 dB or more
Total harmonic distortion rate
0.0012 % or less
Wow and flutter
Value of measurable limit
(±0.001 % W. PEAK) or
less
When a CD is played
HDMI
HDMI
Frequency response
2 Hz to 20 kHz (±0.5 dB)
Dynamic range
100 dB or more
Total harmonic distortion rate
0.0017 % or less
Wow and flutter
Value of measurable limit
(±0.001 % W. PEAK) or
less
DIGITAL
OUT (CD)
OPTICAL*
Jack type
Output
level
Load
impedance
ANALOG
Phono
OUT UNjacks
BALANCED
2 Vrms
(at 50
kilohms)
Over 10
kilohms
ANALOG
XLR
OUT
BALANCED
2 Vrms
(at 50
kilohms)
Over 600
ohms
Square
optical
output
connector
–18 dBm
(Light
emitting
wave
length: 660
nm)
DIGITAL
OUT (CD)
COAXIAL*
Coaxial
output
connector
0.5 Vp-p
75 ohms
PHONES
Stereo
5 mW
phone jack
32 ohms
* Outputs only the audio signals of the CD
Laser Diode Properties
Emission duration:
Continuous
Laser Output*: Less than
44.6 μW
* This output is the value
measurement at a
distance of 200 mm from
the objective lens surface
on the Optical Pick-up
Block with 7 mm
aperture.
Power requirements
North America:
120 V AC, 60 Hz
Europe:
230 V AC, 50/60 Hz
Power consumption
25 W
Power consumption (during standby mode)
0.5 W
Dimensions (w/h/d)
430 × 124 × 390 mm
(17 × 5 × 15 3/8 inch) incl.
projecting parts
Mass (approx.)
10.2 kg (22 lb 8 oz)
Supplied accessories
Audio connecting cord
Remote commander
AC power cord
Battery
Red and White plugs (1)
RM-ASU042 (1)
(1)
R6 (size-AA) (2)
Design and specifications are subject to change
without notice.
SUPER AUDIO CD PLAYER
9-889-205-01
Sony Corporation
2008H05-1
© 2008.08
Audio&Video Business Group
Published by Sony Techno Create Corporation
SCD-XA5400ES
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
FLEXIBLE CIRCUIT BOARD REPAIRING
• Keep the temperature of soldering iron around 270 °C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
This appliance is
classified as a CLASS
1 LASER product.
This marking is
located on the rear
exterior.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs,
screws, and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2 V AC range are suitable. (See
Fig. A)
To Exposed Metal
Parts on Set
0.15 μF
1.5 kΩ
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
AC
voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
2
SAFETY-RELATED COMPONET WARNING!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE
PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
SCD-XA5400ES
TABLE OF CONTENTS
1.
SERVICING NOTES .............................................
4
2.
GENERAL ..................................................................
6
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
Disassembly Flow ...........................................................
Case .................................................................................
Loading Panel Assy ........................................................
Front Panel Assy .............................................................
MAIN Board ...................................................................
Mechanism Deck (CDM66F-DVBU101) .......................
MOTOR Board, Motor (L) Assy (Loading) ...................
Base Unit Block ..............................................................
4.
TEST MODE ............................................................ 12
5.
ELECTRICAL ADJUSTMENT ........................... 16
6.
DIAGRAMS
6-1.
6-2.
6-3.
6-4.
Block Diagram - SA-CD/CD SERVO Section - .............
Block Diagram - HDMI Section -...................................
Block Diagram - MAIN Section -...................................
Block Diagram
- PANEL, POWER SUPPLY Section - ...........................
Printed Wiring Board - MAIN Section (1/2) - ................
Printed Wiring Boards - MAIN Section (2/2) - ..............
Schematic Diagram - MAIN Section (1/4) - ...................
Schematic Diagram - MAIN Section (2/4) - ...................
Schematic Diagram - MAIN Section (3/4) - ...................
Schematic Diagram - MAIN Section (4/4) - ...................
Printed Wiring Board - AUDIO Section (1/2) - ..............
Printed Wiring Boards - AUDIO Section (2/2) - ............
Schematic Diagram - AUDIO Section (1/2) - .................
Schematic Diagram - AUDIO Section (2/2) - .................
Printed Wiring Boards - PANEL Section - .....................
Schematic Diagram - DISPLAY Board - ........................
Schematic Diagram - KEY Section - ..............................
Schematic Diagram - POWER Board - ..........................
Schematic Diagram - STANDBY Board - ......................
Printed Wiring Boards - POWER Section - ....................
6-5.
6-6.
6-7.
6-8.
6-9.
6-10.
6-11.
6-12.
6-13.
6-14.
6-15.
6-16.
6-17.
6-18.
6-19.
6-20.
8
8
9
9
10
10
11
11
17
18
19
20
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
7.
EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
Case Section ....................................................................
DISPLAY Board Section ................................................
Front Panel Section .........................................................
MAIN Board Section ......................................................
AUDIO Board Section ....................................................
Chassis Section ...............................................................
Mechanism Deck Section (CDM66F-DVBU101) ..........
Base Unit Section............................................................
8.
ELECTRICAL PARTS LIST .............................. 55
47
48
49
50
51
52
53
54
Accessories are given in the last of the electrical parts list.
3
SCD-XA5400ES
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
NOTE OF REPLACING THE IC1103 ON THE MAIN
BOARD
IC1103 on the MAIN board cannot exchange with single. When
this part is damaged, exchange the entire mounted board.
MODEL IDENTIFICATION
– Rear View –
Part No.
Model
Part No.
US and Canadian models
3-873-299-1[]
AEP model
3-873-299-2[]
4
Compatible Disc Types
You can play the following types of discs on this player.
• Super Audio CDs
• Audio CDs
• DSD Discs
This player cannot play the following discs.
• CD-ROMs (MP3, JPEG, etc.)
• DVDs
• DTS-CDs
• DualDiscs, etc.
If you try to play CD-ROMs/DVDs, the error message
“Cannot Play” or “No Disc” will appear.
For DTS-CDs/DualDiscs, refer to their respective notes below.
Music discs encoded with copyright protection
technologies
This product is designed to play back discs that conform to the Compact
Disc (CD) standard.
Recently, various music discs encoded with copyright protection
technologies are marketed by some record companies. Please be aware
that among those discs, there are some that do not conform to the CD
standard and may not be playable by this product.
Notes on CD-R/CD-RW playback
Discs recorded on CD-R/CD-RW drives may not be played back because
of scratches, dirt, recording condition, or the drive’s characteristics.
Besides, the discs, which are not yet finalized at the end of recording,
cannot be played back. In these cases, “Reading” will remain or
“Cannot Play” will appear on the display.
Note on DTS-CDs
DTS signals are output from the DIGITAL OUT (CD) jacks only.
The DTS signals must be decoded on a DTS-compliant digital device to
be listened to.
Note on DualDiscs
A DualDisc is a two sided disc product which mates DVD recorded
material on one side with digital audio material on the other side.
However, since the audio material side does not conform to the Compact
Disc (CD) standard, playback on this product is not guaranteed.
Note on DSD Discs
A DSD Disc is a disc recorded in the DSF file format.
This player can play DSF files that you have recorded on DVD-ROM
compatible DVD-R, DVD-RW, DVD+R and DVD+RW discs. For details
on DSD Discs.
SCD-XA5400ES
HOW TO OPEN THE TRAY WHEN POWER SWITCH TURNS OFF
"
#
– BOTTOM VIEW –
cam (66)
Pull out the tray
in the direction of arrow #.
Rotate the cam (66)
with a tapering driver
in the direction of arrow ".
MAIN BOARD SERVICE POSITION
In checking the MAIN board, prepare jig (extension cable J-2501-102-A: 1 mm Pitch, 13 cores, Length 300 mm).
AUDIO board
(CN151)
connect jig (extension cable J-2501-102-A) to
MAIN board (CN501, CN1100) and
AUDIO board (CN151, CN152).
MAIN board
(CN1100)
AUDIO board
(CN152)
insulator sheet
Note: insert the insulator sheet to prevent short.
MAIN board
(CN501)
PRECAUTION WHEN REMOVING OPTICAL PICK-UP BLOCK OR DMB-FIT BOARD
CAUTION
Be sure to execute a solder bridge as a measure against
static electricity when removing the optical pick-up or
DMB-FIT board.
(Otherwise, the OP block will be destroyed.)
– BOTTOM VIEW –
mechanism deck
5
SCD-XA5400ES
SECTION 2
GENERAL
This section is extracted
from instruction manual.
Front Panel
" / (power) switch
Turns the power of the player on or off.
To let the player enter power-saving mode
(standby mode), press =/ (power) on the remote
or on the player.
# TIME/TEXT button
Switches the playing time of the track, the
remaining time of the disc, or TEXT information
on the display.
$ MULTI/2CH button
Selects the playback area when a disc with the 2channel area and the multi-channel area (page 8) is
loaded.
% SA-CD/CD button
Switches between the Super Audio CD layer and
the CD layer of a hybrid disc.
& HDMI button/lamp
Sets whether the audio signal is output from the
HDMI OUT jack or not.
When the lamp is lit, sound is output from the
HDMI OUT jack.
When the lamp is not lit, sound is output from the
ANALOG OUT jacks and DIGITAL OUT (CD)
jacks.
* 9 button and lamp
Pauses playback. The lamp lights up during
playback pause.
' Disc tray
Holds a disc.
- Display window
Displays information on the disc or current track.
( " button
Opens and closes the disc tray.
. Remote sensor
Receives the signal from the remote.
) / button and lamp
Plays a disc. The lamp lights up during playback.
/ PHONE LEVEL
Adjusts the headphones volume.
+ Y button
Stops playback
, AMS dial (AMS: Automatic Music
Sensor)
Selects a track.
0 PHONES jack
Connects the headphones.
Rear Panel
" IR REMOTE IN jack
Equipped on the models for the U.S. and Canada
only.
Connects an IR repeater.
# ANALOG OUT BALANCED L/R jacks
Connects a component with XLR input jacks, such
as stereo amplifiers, etc., using an XLR (balanced)
cable (not supplied).
$ HDMI PRIORITY MULTI/2CH switch
When both multi-channel area and 2-channel area
are recorded on a Super Audio CD layer, sets the
area that is given priority to be played back.
% HDMI OUT jack
Connects components with HDMI jacks, such as
HDMI-compliant amplifiers, etc.
& DIGITAL OUT (CD) COAXIAL jack
Connects a component with the coaxial digital
input jack, such an MD deck, etc.
' DIGITAL OUT (CD) OPTICAL jack
Connects a component with the optical digital
input jack, such an MD deck, etc.
( DIGITAL OUT (CD) ON/OFF switch
Sets whether audio signals are output from the
DIGITAL OUT (CD) jacks or not.
) AC IN jack
Connects the supplied AC power cord (mains
lead).
About the IR REMOTE jack
You can operate the player without pointing the
remote toward the remote sensor of the player if
you connect an IR repeater (not supplied) to the
IR REMOTE jack.
Use an IR repeater when you install the player in
a place where signals from the remote cannot
reach.
SCD-XA5400ES
IR repeater
(not supplied)
* ANALOG OUT UNBALANCED L/R jacks
Connects a component with analog input jacks,
such as stereo amplifiers, etc., using an audio
connecting cord.
RM-ASU042
6
SCD-XA5400ES
Remote
# SA-CD/CD button
Switches between the Super Audio CD layer and
the CD layer of a hybrid disc.
$ HDMI button
Sets whether the audio signal is output from the
HDMI OUT jack or not.
% REPEAT button
Performs Repeat Play.
Inserting batteries into the
remote
Insert two R6 (size-AA) batteries into the
battery compartment with the + and – correctly
oriented to the markings. When using the
remote, point it at the remote sensor
on the
player.
& SHUFFLE button
Performs Shuffle Play.
' ENTER button
Select a track directly.
( / button
9 button
Y button
Plays back discs, pauses playback, and stops
playback.
) AMS buttons (AMS: Automatic
Music Sensor)
Selects a track.
* N. buttons
Fast-forwards or fast-reverses the track during
playback.
+ DISPLAY button
Turns the display information off or on.
, TIME/TEXT button
Switches the playing time of the track, the
remaining time of the disc, or TEXT information
on the display.
- CLEAR button
Resumes Continuous Play from Repeat Play or
Shuffle Play.
. Number buttons
Select a track directly.
Tip
Under normal conditions, the batteries should last for
about 6 months. When the remote no longer operates
the player, replace both batteries with new ones.
Notes
• Do not leave the remote in an extremely hot or a
humid place.
• Do not drop any foreign object into the remote
casing, particularly when replacing the batteries.
• Do not use a new battery with an old one.
• Do not expose the remote sensor to direct sunlight or
lighting apparatus. Doing so may cause a
malfunction.
• If you do not intend to use the remote for an extended
period of time, remove the batteries to avoid possible
damage from battery leakage and corrosion.
/ CONTINUE button
Resumes Continuous Play from Shuffle Play.
" / (power) switch
Turns the power of the player on or off.
To let the player enter power-saving mode
(standby mode), press =/ (power) on the remote
or on the player.
0 MULTI/2CH button
Selects the playback area when a disc with the 2channel area and the multi-channel area is loaded.
1 ; button
Opens or closes the disc tray.
7
SCD-XA5400ES
SECTION 3
DISASSEMBLY
•
This set can be disassembled in the order shown below.
3-1.
DISASSEMBLY FLOW
SET
3-2. CASE
(Page 8)
3-3. LOADING PANEL ASSY
(Page 9)
3-4. FRONT PANEL ASSY
(Page 9)
3-5. MAIN BOARD
(Page 10)
3-6. MECHANISM DECK
(CDM66F-DVBU101)
(Page 10)
3-7. MOTOR BOARD,
MOTOR (L) ASSY (LOADING)
(Page 11)
3-8. BASE UNIT
BLOCK
(Page 11)
Note: Follow the disassembly procedure in the numerical order given.
3-2.
CASE
case
two screws
(BVST4 × 8)
flat head screw
(TP)
two screws
(BVST4 × 8)
8
SCD-XA5400ES
3-3.
LOADING PANEL ASSY
Pull out the tray
in the direction of arrow #.
loading panel assy
two screws
(BVTP2.6 (3CR))
#
"
– BOTTOM VIEW –
cam (66)
Rotate the cam (66)
with a tapering driver
in the direction of arrow ".
3-4.
FRONT PANEL ASSY
two cushions
wire (flat type) (19 core)
(CN502)
two screws
(BVTP3 × 8)
two brackets
(panel)
connector
(CN291)
connector
(CN103)
six screws
(BV/ring)
front panel assy
9
SCD-XA5400ES
3-5.
MAIN BOARD
connector (CN506, CN1201, CN1202)
six screws
(BVTP3 × 8)
wire (flat type) (24 core)
(CN1101)
R MAIN board
wire (flat type) (13 core)
(CN1100)
wire (flat type) (19 core)
(CN502)
wire (flat type) (13 core)
(CN501)
two screws
(BVTP3 × 8)
screw
(B3 × 6)
3-6.
MECHANISM DECK (CDM66F-DVBU101)
three screws
(BVTP3 × 8)
connector
(CN1201)
wire (flat type) (24 core)
(CN1101)
mechanism deck
(CDM66F-DVBU101)
10
connector
(CN010)
SCD-XA5400ES
3-7.
MOTOR BOARD, MOTOR (L) ASSY (LOADING)
belt (LD)
gear (LD)
two screws
(B2.6 × 4)
connector
(CN012)
cushion
two claws
tray (66F)
RB motor (L) assy
(loading)
Remove two solders.
R MOTOR board
3-8.
BASE UNIT BLOCK
– BOTTOM VIEW –
cam (66)
base unit block
floating screw (DIA.12)
base unit block
11
SCD-XA5400ES
SECTION 4
TEST MODE
Note 1: According to the following procedures when you ship it
(Return it to the customer).
1. SERVICE MODE of step 6 and 7
(DVD EEPROM clearness)
2. COLD RESET
Note 2: “DVD” displayed by the test mode shows "super audio
CD”.
COLD RESET
The cold reset clears data stored in microcomputer’s RAM to initial conditions.
Procedure:
1. Press three buttons of [x], [A] and [?/1] on the set simultaneously.
2. “COLD RESET” appears on the fluorescent indicator tube. After that, the fluorescent indicator tube becomes blank then the
system becomes standby states.
PANEL TEST
Procedure:
1. Press the [?/1] button to turn on.
2. Press three buttons of [x], [. AMS >, PUSH ENTER]
and [?/1] on the set simultaneously.
3. All segments turned on.
4. When [x] button on the set is pressed after half segments in
fluorescent indicator tube light up. If you press [x] button on
the set again, another half segments in fluorescent indicator
tube light up. Pressing [x] button on the set again would cause
all segments in fluorescent indicator tube light up.
5. Press [N] button on the set, in the key check mode, the fluorescent indicator tube displays “K0 J0”.
6. Each time an another button is pressed, “KEY” value increases. However, once a button is pressed, it is no longer taken into
account. When all keys are pressed correctly, “K10” and “OK”
are alternately displayed.
7. When the [. AMS >, PUSH ENTER] dial on the set is
turned in the direction of right,“J0” is changed to “J1”, then ...
“J9”. When the [. AMS >, PUSH ENTER] dial on the
set is turned in the direction of left, “J0” is changed to “J9”,
then ... “J0”.
8. To release from this mode, press three buttons in the same
manner as step 1.
12
CDM TEST
Aging test mode of CDM.
Procedure:
1. Press three buttons of [X], [A] and [?/1] on the set simultaneously.
2. After the “Open” display blinks, “SINGLE LOADING” is displayed on the fluorescent indicator tube.
3. Press [. AMS >, PUSH ENTER] and then aging starts.
4. To stop aging, Press [x] button.
5. To release from this mode, press three buttons of [X], [A] and
[?/1] on the set simultaneously.
SERVICE MODE
When HDMI is connected in this mode, various information is displayed on the fluorescent indicator tube. Refer to the following
table for displayed various information.
EEPROM CLEAR
Procedure:
1. Press two buttons of [x] and [A] on the set simultaneously for
3 seconds.
2. Various information is displayed on the fluorescent indicator
tube.
3. When [R] button is pressed of the remote commander. Rebooting emergence fuctor appears of toggle article number on the
fluorescent indicator tube.
4. When [t] button is pressed of the remote commander. MTK
communication error factor appears of toggle article number
on the fluorescent indicator tube.
5. When [r] button is pressed of the remote commander. Power
ON/OFF error factor appears of toggle article number on the
fluorescent indicator tube.
6. Press the button in order of the [4] t [Time/Text] t [CLEAR]
on the remote commander of attachment.
7. The message “Complete” is displayed on the fluorescent indicator tube, and DVD EEPROM is cleared.
8. To release from this mode, disconnect the power cord.
Note: Don't press the [?/1] button when to release from this mode.
Necessarily disconnect the power cord. The set doesn't operate
when turning off power with [?/1] button of the set.
SCD-XA5400ES
List of trouble log
Note: “nnn” of toggle article number is a generation frequency of the error.
Type
Test key
Toggle article
(Remote commander)
number
Rebooting emergence
(Rebooting emergence Test key2 (R)
factor)
Serial communications
(MTK communication
Test key3 (t)
error factor)
MTK power control
(Power ON/OFF error
factor)
Test key2 (r)
Content
2Annn
It was not possible to communicate with MTK five seconds more continuously
2Bnnn
Compulsion power off demand was received from MTK
2Cnnn
Only MTK reset it
(Distination, model and region for are the disagreements)
2Dnnn
Fails in the start of MTK
2Ennn
Fails in the switch of the input mode of MTK
2Fnnn
Input mode of MTK changed without permission
2Gnnn
Reacts to the key notification no though the communication with MTK is
alive
3Annn
It was not possible to communicate with MTK with 48ms
3Bnnn
A non-standard packet length was received (Excluding 16 bytes)
3Cnnn
Checksum NG
3Dnnn
Type of the communication header is NG
3Ennn
PEQ data reading operation (8032tDVDLIB) terminated abnormally
3Fnnn
PEQ data writing operation (DVDLIBt8032) terminated abnormally
4Annn
Fails in AC ON Initial
4Bnnn
Fails in power on of MTK
4Cnnn
Initialization response of CDM is abnormal
4Dnnn
CDM mechanism error notification is received
4Ennn
Input mode is NG MTK is started
4Fnnn
MTK input mode switch at time fails usually
4Gnnn
Fails in power off of MTK
4Hnnn
Fails in power off of CDM
13
SCD-XA5400ES
DVD SERVICE MODE
Note: DVD SERVICE MODE is a service mode of super audio
CD.
When the DVD service mode is operated, the following, remote
commander is necessary.
(The DVD service mode cannot be operated by remote commander
to which this machine is attached)
Remote commander (RM-ASP003) (for US, Canadian models):
Part No. 1-479-272-11
Remote commander (RM-ASP004) (for AEP model):
Part No. 1-479-272-21
Note: Above-mentioned remote commander is one example. If it is the
one printed under a remote commander as "DVD", any remote commander can be operated.
1. DVD Service Mode General Description
This mode let you make diagnosis and adjustment easily by using the remote commander and the TV screen for HDMI input.
The instructions, diagnostic results, etc. are given on the on-screen
display.
Be sure to execute the IOP measurement when a base unit is replaced.
2. Enterring DVD Service Mode
Procedure:
1. Press the [?/1] button to turn the power on.
2. Press two buttons of [x] and [A] on the set simultaneously for
3 seconds
3. The message “SERVICE IN” appears on the fluorescent indicator tube and top menu of the Remocon Diagnosis Menu
appears on the on-screen display on the TV screen for HDMI
input as follows. The model name, IF-con version and Syscon
version are displayed at the bottom of the on-screen display.
Remocon Diagnosis Menu
0.
1.
2.
3.
4.
External Chip Check
Servo Parameter Check
Drive Manual Operation
Emergency History
Version Information
Model Name :xxxx_xx
IF-con:Ver.xx.xx(xxxx)
Syscon:Ver.x.xxx
4. To execute each function, press its number by using numeric
button on the remote commander.
5. To release from this mode, disconnect the power cord.
Note: Don't press the [?/1] button when to release from this mode.
Necessarily disconnect the power cord. The set doesn't operate
when turning off power with [?/1] button of the set.
3. Executing IOP Measurement
In order to execute IOP measurement, the following standard procedures must be followed.
Procedure:
1. From the top menu of Remocon Diagnosis Menu, select “2
Drive Manual Operation” by pressing the [2] button on the
remote commander. The following screen appears on the onscreen display
Drive Manual Operation
1.
2.
3.
4.
5.
0.
Servo Control
Track/Layer Jump
Manual Adjustment
Mecha test mode
MIRR time Adjust
Return to Top Menu
2. Select “3. Manual Adjustment” by pressing the [3] button on
the remote commander. The following screen appears on the
on-screen display.
Manual Adjust
1. Track Balance Adjust:
2. Track Gain Adjust:
3. Focus Balance Adjust:
4. Focus Gain Adjust:
5. Eq Boost Adjust:
6. Iop:
7. TRV. Level:
8. S curve(FE) Level:
9. RFL(PI) Level:
0. MIRR Time:
[V][v] Change Value
[RETURN]Return to previous menu
3. Select “6. Iop:” by pressing [6] button on the remote commander.
4. Wait until a hexadecimal number appear in the on-screen display as below.
Manual Adjust
1. Track Balance Adjust:
2. Track Gain Adjust:
3. Focus Balance Adjust:
4. Focus Gain Adjust:
5. Eq Boost Adjust:
6. Iop: xx
7. TRV. Level:
8. S curve(FE) Level:
9. RFL(PI) Level:
0. MIRR Time:
[V][v] Change Value
[RETURN]Return to previous menu
5. Convert data from hexadecimal to decimal by using conversion table.
6. If the value is smaller than 93 (decimal), then it is OK. However if the value is higher than 93, then BU (base unit) is defective and need to be change.
14
SCD-XA5400ES
7. Press the [O RETURN] button on the remote commander to
return to previous menu.
8. Press the [0] button on the remote commander to return to the
top menu of Remocon Diagnosis Menu.
9. Disconnect the power cord to turn off.
Note: Don't press the [?/1] button when to release from this mode.
Necessarily disconnect the power cord. The set doesn't operate
when turning off power with [?/1] button of the set.
4. Checking Emergency History
To check the emergency history, please follow the following procedure.
Procedure:
1. From the top menu of Remocon Diagnosis Menu, select “3.
Emergency History” by pressing the [3] button on the remote
commander. The following screen appears on the on-screen
display.
Emg. History Check
Laser Hours
CD
999h 59min
DVD
999h 59min
01. 01 05 04 04
00 00 00 00
00 92 46 00
00 00 23 45
02. 02 02 01 01
00 00 00 00
00 A9 4B 00
00 00 23 45
[Next]Next page [Prev]Prev page
[0]Return to Top Menu
2. You can check the total time when the laser is turned on during
playback of super audio CD and CD from the above menu. The
maximum time, which can be displayed are 999h 59min.
3. You can check the error code of latest 10 emergency history
from the above menu. To view the previous or next page of
emergency history, press the [.] or [>] button on the remote commander. The error code consists of three kinds of
error codes.
A. Error code
Example of Error code
01. 01 05 04 04
00 00 00 00
00 92 46 00
00 00 23 45
The meaning of error code is as below:
01: Communication error (No reply from syscon)
02: Syscon hung up
03: Power OFF request when syscon hung up
19: Thermal shutdown
24: MoveSledHome error
25: Mechanical move error (5 changer)
26: Mechanical move stack error
30: DC motor adjustment error
31: DPD offset adjustment error
32: TE balance adjustment error
33. TE sensor adjustment error
34. TE loop gain adjustment error
35. FE loop gain adjustment error
36. Bad jitter after adjustment
40. Focus NG
42. Focus layer jump NG
51: Spindle stop error
52. Open kick spindle error
60: Focus on error
61: Seek fail error
62: Read Q data/ID error
70: Lead in data read fail
71: TOC read time out (CD)
80: Can’t buffering
81: Unknown media type
B. Parameter of error code
This is the detail of error code.
Example of Error code
01. 01 05 04 04
00 00 00 00
00 92 46 00
00 00 23 45
C. Time of error code
This is the laser time when an error occurred.
Example of Error code
01. 01 05 04 04
00 00 00 00
00 92 46 00
00 00 23 45
To Clear the Laser Hour
Press the [DISPLAY] button on the remote commander and then
press the [CLEAR] button on the remote commander. The data for
both super audio CD and CD data are reset.
Emg. History Check
Laser Hours
CD
0h
0min
DVD
0h
0min
01. 01 05 04 04
00 00 00 00
00 92 46 00
00 00 23 45
02. 02 02 01 01
00 00 00 00
00 A9 4B 00
00 00 23 45
[Next]Next page [Prev]Prev page
[0]Return to Top Menu
To Clear the Emergency History
Press the [TOP MENU] button on the remote commander and then
press the [CLEAR] button on the remote commander. The error
code for all emergency history would be reset.
Emg. History Check
Laser Hours
CD
999h 59min
DVD
999h 59min
01. 00 00 00 00
00 00 00 00
00 00 00 00
00 00 00 00
02. 00 00 00 00
00 00 00 00
00 00 00 00
00 00 00 00
[Next]Next page [Prev]Prev page
[0]Return to Top Menu
15
SCD-XA5400ES
SECTION 5
ELECTRICAL ADJUSTMENT
To Execute the Initialize Setup Data
Procedure:
1. Press the [MENU] button on the remote commander and then
press the [CLEAR] button on the remote commander. The following screen appears on the on-screen display.
Emg. History Check
Laser Hours
CD
999h 59min
DVD
999h 59min
Initialize setup data...
[Next]Next page [Prev]Prev page
[0]Return to Top Menu
2. The screen after a while returns to former display.
To Return to the Top Menu of Remocon Diagnosis
Menu
Press the [0] button on the remote commander.
5. Checking Version Information
To check the version information, please follow the following procedure.
Procedure:
1. From the top menu of Remocon Diagnosis Menu, select “4.
Version Information” by pressing the [4] button on the remote
commander. The following screen appears on the on-screen
display.
Version information
Firm(Main): Ver. X.XXXX
Firm(Sub): XX.XX
RISC: XXXXXX
8032: XXXXXX
Audio DSP: XX.XX.XX.XX
Servo DSP: XX.XX.XX.XX
[0]Return to Top Menu
2. To return to the top menu of Remocon Diagnosis Menu, press
the [0] on the remote commander.
16
When the base unit is replaced, perform the adjustment and the
measurement as shown below in this order.
EXECUTING IOP MEASUREMENT (See page 14)
SCD-XA5400ES
SECTION 6
DIAGRAMS
6-1.
BLOCK DIAGRAM - SA-CD/CD SERVO Section -
RF
R-ch is omitted due to same as L-ch.
• SIGNAL PATH
: SA-CD PLAY
10 DVDRFIP
VOA/A
VOB/B
6
7
8
9
VOC/C
VOD/D
DVDA
DVDB
DVDC
DVDD
: CD PLAY (ANALOG)
: CD PLAY (DIGITAL)
J1701
11
12
13
14
OPTICAL PICK-UP
BLOCK
(KHM-313CAB)
VC
SPDIF 215
COAXIAL
OPTICAL
TRANSMITTER
IC1701
LEVEL SHIFT
IC1703
22 LDO1
ABCK
ALRCK
KMOD
ASDATA3
PBCK
PLRCK
SBCK
PDT
204
205
213
222
19 MDI1
20 MDI2
OPTICAL
PDT, BDTR, PBCK,
PLRCK, SBCK
MULTIPLEXER
IC1901
ASDATA 226
21 LDO2
1Y 1
15 Ycom
C
B
AUTO POWER
CONTROL (FOR SA-CD)
Q1102-2
DIGITAL
OUT(CD)
RF AMP, SERVO DSP,
HDMI TRANSMITTER
IC1101 (1/2)
28 V2O
AUTO POWER
CONTROL (FOR CD)
Q1102-1
PD
LD (650)
NA
NB
MC
MD
53 LIMIT SW
LIMIT
LD (780)
LEVEL SHIFT
IC1702
17 TNI
18 TPI
VOE/E+G
VOF/F+H
0Y 2
BDTL
R-CH
9 10
VR (650)
SA-CD ON
SWITCH
Q1101-2
54 MSW
SYSTEM CONTROLLER
IC501 (1/4)
WIDE 209
Q1103
MSW
VR (780)
CD ON
SWITCH
Q1101-2
VCC
42
41
15
BUFFER
VREF 43
FCS+
FCS-
36
37
FOCUS COIL
DRIVE
48
1
TRK+
TRK-
35
34
TRACKING COIL
DRIVE
3
4
9
10
12
13
16
17
40
6
7
45
19
20
22
21
IN+3
REG01
32
REG02
31
30
29
SLSL+
SP+
SP-
27
28
46
47
M001
(LOADING)
SCD-XA5400ES
M
25
24
IN4+
BUFFER
SLED MOTOR
DRIVE
SPINDLE MOTOR
DRIVE
MUTE123
MUTE4
TSD_M
PS
BUFFER
43 STT_D/P
45 DMUTE
44 STT_M/2
DSEL 210
TRG_SW 211
FOCUS/TRACKING COIL DRIVE,
SPINDLE SLED, LOADING MOTOR DRIVE
IC1201
IFCK 98
37 DVD_SCO
IFSDO 97
IFSDI 100
xIFCS 99
32 DVD_SOD
31 DVD_SID
37 DVD XIFCS
D+3.3V
29 V REFO
252 RFRAPC
41 FOO
34 DVD_XIFBUSY
xIFBSY 110
40 TRO
37 FMO
36 DMO
94 FWD
95 REV
39 IOPMON
SW010
(CHUCKING)
35
157
158
130
OP_INP
MUTE123
MUTE
TSD_M
83 CKSW
84 OCSW
SW011
(DISC IN/OUT)
MCS
17
17
A
(Page 19)
SCD-XA5400ES
6-2.
BLOCK DIAGRAM - HDMI Section -
(Page 19)
B
27M
REAMP, SERVO DSP, HDMI TRANSMITTER
IC1101 (2/2)
121-119,117-113,
129-122
140, 141, 143, 144
155, 150, 139, 149
A0 – A11
2,4,5,7,8,10,11,13,42,
44,45,47,48,50,51,53
DQ0 – DQ15
23 – 26,
29 – 34, 22, 35
SD-RAM
IC1104
20
21
38
19
16
18
17
15
39
37
137
138
146
136
133
135
134
111
132
147
BA0
BA1
CLK
CS
WE
RAS
CAS
LDQM
UDQM
CLKE
XTALI 239
RD0 – RD15
RA0 – RA11
BA0
BA1
DRCLK
_RCS
_RWE
_RAS
_CAS
DQM0
DQM1
CKE
SDA 102
SCL 101
EEWP 112
TX2P
TX2N
TX1P
TX1N
TX0P
TX0N
TXCP
TXCN
• SIGNALPATH
EEPROM
IC1103
: SA-CD PLAY
5 SDA
6 SCL
7 WE
CN1701
HDMI OUT
1
3
4
6
7
9
10
12
180
179
177
176
174
173
171
170
HTPLG 162
LEVEL SHIFT
IC1705
AVDD3 165
AVDD3 166
B+ SWITCH
Q1105
DDC_CLK 161
DDC_DAC 159
LEVEL SHIFT
Q1701
TMDS DATA2+
TMDS DATA2–
TMDS DATA1+
TMDS DATA1–
TMDS DATA0+
TMDS DATA0–
TMDS CLOCK+
TMDS CLOCK–
19 HPD
SW+3.3V
SW+6V
+5V REGULATOR
IC1707
18 +5V POWER
29, 31, 33, 35,
38, 40, 42, 44
DQ0 – DQ7
79, 80, 82 – 86, 89
FLASH ROM
IC1102
HD0 – HD7
SYSTEM CONTROLLER
IC501 (2/4)
SCD-XA5400ES
25 – 18, 8 – 1,
48, 17, 16, 9, 10
97, 56 – 62, 74 – 67,
91, 63, 64, 75, 87
DQ15/A-1 45
A0 – A19,
N.C
38 MTK_RST
HA0 – HA21
CE 26
OE 28
WE 11
76 XROMCS
78 XRD
66 XWR
RESET 12
108 xSYSRST
18
15 SCL
16 SDA
18
X501
5MHz
13 XOUT
15 XIN
CSC_RX_IN 3
CEC_TX_OUT 22
CEC DATA SWITCH
Q9724, 9726, 9728, 9729
13 CEC
SCD-XA5400ES
6-3.
BLOCK DIAGRAM - MAIN Section -
(Page 17)
A
PDT, BDTR, PBCK,
PLRCK, SBCK
PDT
5 PDATA
BDTR
SWITCHING
IC206
R-CH
PBCK
PLRCK
1 DSDL
2 DSDR
IOUTR+ 17
IOUTR- 18
INVERTER
IC292
J252
R
3
RELAY DRIVE
Q252, 253
D/A CONVERTER
IC202
D-FLIP FLOP
IC155
IOUTL+ 25
IOUTL- 26
B
1 4 2
LOW-PASS FILTER
IC255
4 PBCK
6 PLRCK
SBCK
(Page 18)
BUFFER
IC253
RY252
BUFFER
IC203
1 4 2
3
LOW-PASS FILTER
IC205
J202
L
ANALOG OUT
UNBALANCED
27M
7 SCK
COUNTER
IC156
RELAY DRIVE
Q202, 203
3 AB CK
RY202
CLOCK
BUFFER
IC152
CLOCK GENERATOR
IC151
10
11
12
14
CLKP 15
2 REF
SCL
SDA
X151
22.5792MHz
J251
R
BUFFER
IC204
MS
MDI
MDO
RST
J201
L
1 2
RELAY DRIVE
Q201, 204
RY201
RELAY
CONTROL
Q151, 293
R-ch is omitted due to same as L-ch.
• SIGNAL PATH
LINE AMP
IC291
: SA-CD
RV801
PHONE LEVEL
-1
J801
PHONES
-2
SCD-XA5400ES
DAC_CS2
DAC_CS1
DAC_DATA
DAC_CLK
DAC_INT
SYSTEM CONTROLLER
IC501 (3/4)
19
6
19
ASDMUTE
87 88 30 28 85
XAMUTE
78 77
PLL_IC_ISC_SCL
PLL_IC_I2C_SDA
AC_DET
19
C
(Page 20)
SCD-XA5400ES
6-4.
BLOCK DIAGRAM - PANEL, POWER SUPPLY Section -
4 – 39
40 – 54
GRID DRIVE
Q802
DAT
CLK
XCS
XRST
63
62
61
60
SYSTEM CONTROLLER
IC501 (4/4)
24 FL_O_OUT
21 FL_CLK
23 FL_STB
+3.3V
REGULATOR
IC153
RY+3.3V
G2 – 15
ND801
FLUORESCENT
INDICATOR TUBE
AD1, S1 – 35
FLUORESCENT INDICATOR
TUBE DRIVER
IC802
PT003
MAIN POWER
TRANSFORMER
+12V
REGULATOR
IC106
AMP+12V
RECT
D121 – 124
40 G1
–12V
REGULATOR
IC107
AMP–12V
D802
/
LED DRIVE
Q803
89 LED_PLAY
D803
9
LED DRIVE
Q804
90 LED_PAUSE
DAC+3.3V
+3.3V
REGULATOR
IC201
CL+3.3V
+3.3V
REGULATOR
IC154
+5V
REGULATOR
IC105
RECT
D121 – 124
SW+6V
LED DRIVE
Q801
SW+5V
91 LED_HDMI
S805
HDMI
S801 – 804
97 KEY0
S807 – 810
95 KEY1
RF+3.3V
+3.3V
REGULATOR
IC1107
DSP+3.3V
+3.3V
REGULATOR
IC1105
+5V
REGULATOR
IC505
+6V
REGULATOR
IC104
RECT
D117 – 120
+1.8V
REGULATOR
IC1110
+3.3V
REGULATOR
IC506
+4V
REGULATOR
IC103
RECT
D113 – 116
+3.3V
DSP+1.8V
AMS
PUSH ENTER
ROTARY
ENCODER
S805
94 KEY3
10 EN_A
11 EN_B
PT002
MAIN POWER
TRANSFORMER
IR REMOTE
IN
COM 1
+3.3V
REGULATOR
IC803
FL+6V
+6V
REGULATOR
IC101
RECT
D105 – 108
DISPLAY-27V
-27V
REGULATOR
Q101
RECT
D101 – 104
4 SIRCS_IN
7 CH0
REMOTE
CONTROL
TRANSMITTER
REMOTE CONTROL
RECEIVER
IC801
FL+3.3V
P_CONT1 39
6 CH1
D890
+9V
REGULATOR
IC504
RECT
D109 – 112
SIRCS
SELECT SWITCH
IC692
REMOTE CONTROL
RECEIVER
IC693
M+9V
+10V
REGULATOR
IC102
(US, Canadian)
J691
F002
(AEP)
F001
RY01
S501
OFF
DIGITAL
OUT(CD)
ON
S502
MULTI
HDMI
PRIORITY
2CH
55 XDOUT_EN
RELAY DRIVE
Q52
P_CONT0 41
D502
56 MULTI_PRIO
E3.3V
C
AC_OUT 20
RESET 12
E3.3V
RESET SIGNAL
GENERATOR
IC503
RESET
SWITCH
Q503
+4V
REGULATOR
IC51
(Page 19)
20
20
T002
SUB POWER
TRANSFORMER
RECT
D52 – 55
AC
DETECT
Q51
AC_DET
SCD-XA5400ES
+3.2V
REGULATOR
IC52
(AC IN)
D56, 57
L51
LINE FILTER
SCD-XA5400ES
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
For Printed Wiring Boards.
For Schematic Diagrams.
Note:
• X : Parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
f : internal component.
: Pattern from the side which enables seeing.
•
(The other layers' patterns are not indicated.)
Note:
• All capacitors are in μF unless otherwise noted. (p: pF) 50
WV or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : internal component.
• C : panel designation.
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• AUDIO and MAIN boards are multi-layer printed board.
However, the patterns of intermediate layers have not
been included in diagrams.
• Indication of transistor.
C
Q
These are omitted.
B E
Q
B
C
E
These are omitted.
SCD-XA5400ES
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
• Circuit Boards Location
OUT-SW board
STANDBY board
MOTOR board
MAIN board
KEY-L board
Note:
Les composants identifiés
par une marque 0 sont
critiques pour la sécurité.
Ne les remplacer que par
une piéce portant le numéro spécifié.
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : SA-CD PLAY
(
): CD PLAY
• Voltages are taken with VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F
: SA-CD PLAY
J
: CD PLAY (ANALOG)
c : CD PLAY (DIGITAL)
• Abbreviation
CND : Canadian model
AUDIO board
HP board
POWER board
DISPLAY board
LED board
JOG board
21
21
KEY-R board
SCD-XA5400ES
PRINTED WIRING BOARD - MAIN Section (1/2) - • See page 21 for Circuit Boards Location. •
3
4
5
6
7
8
12
CL1168
R1109
R1110
R1124
CL1107
C1B1 E2
Q1102
C1105
E1 B2 C2
R1142
C1112
E
R1137
R1138
CL1114
CL1113
24
23
CL1112
2
CN1101
1
CL1106
C1101
R1102
CL1301
24
Q1103
R1108
R1116
D2
CL1303
R2110
E B R1111
G1D1
R1117
Q1101
C1221
C1224
C1219
S2 G2 S1
CL1302
CL1305 CL1304
R1231
R585
CL1208
R569
R568
81
50
51
R1236
D693
R693
R694
C693
R697
CL515
R508
CL516
(AEP)
R501
R514
R512
R510
R506
R504
R544
R543
R542
R604
R603
80
R586
R525
R534
R546
R545
R524
CL511 CN501
R589
CL512
D502
R599
R590
R598
C1225
C1226
R1239
1
2
CL513
CL514
R597
R596
B
CL519
R530
13
12
AUDIO BOARD
CN152
(Page 28)
R535
C533
R533
18
2
C531
R526
EB503
CN502
R1238
R1243
R695
R561
E B
R531
R528
R513
R511
R509
CL501
CL500
1 4
C1220
C1218
R1247
R1246
100
IC501
R1225 R1223
R1226 R1221
C1211 C1209
R1220 C1233
C1205
37
36 C1215
C1223
C1222
D505
1
31
C1214 CL1206
25
R696
5
1 4
R1212 CL1213
C1212
C1217
C1119
C1118
R1214
1
48
IC1201
C1117
CL1116 CL1118
R1204
R1209 R1208
R1216
CL1204
C1210 C1208CL1203 C1203 R1215
R1224
R1219
12
13
R1229
C1213
R1139
CL2155
CL2109
R9924
R1210
24
C692
R588
R587
CL1115 CL1117
CL1108
1
R519
R518
R520
R559
R521
R522
R523
R551
R650
CL517
IC692 8
R515
30
R601
R602
R1206
IC1102
64
CL2154 CL1110
B E
R9934
C9972
RB1112
CL1105
CL1101
C1136
Q9724
C691
R538 R536
JL577
R9935
R9929
R9941
R9920
EB
EB
Q9728 Q9726 R9928
25
C1195
R1123
C1113
R1114
CL2104
R1121
R1120
R1118
R1115
R1113
R1107
R1112
CL2103
(Page 28)
C1111
5
4
65
1
C1133
C1132
R1136
C1187
IC1107
CL1167
13
256
R516
(US, CND)
CL518
R557
CL502
CL503 X501
Q503
CL507
CL504
R9945
Q9729
1
D9712
C1110
48
CL1121 R2176
C1148
C1147
C1139
C1138
C1137
8
3
C523
1
C521
D501
R584
R583
C1193
1
C1192 3
CL1163
CL1166
CL2119
CL2118
C1183
C1198
2
R1156
R2115
CL1123
CL1160
CL2101
CL2102
IC1101
C1135
3 2
RB1113
4 CL1702 R1746
5
R1233
R1230
CL1207
1
CN1110
AUDIO
BOARD
CN151
3
IC1110
CL1164
A
R1151
5
R2133
4
C1182
CL1900
CL1165
1
128
RB1109 R1191
R1193
RB1110
C1206
CL1202
C1184
CL1162
129
FB1111
CL1201
IC11051
D
RB1111
R1185
C1186
CL1161
R1786 RB1114 R2114
R2187
R1146
IC1103
C520
CL506
R556
R1207
C1145
R563
R562
CL505
RB1108 RB1107
RB1104 RB1103
R1785 RB1115
4
5
C522
FB1108
FB1106
54
R1160
R1161
R1143
9
C1190
28
IC1705
IC503
CL1205
IC1901
D2
G1
S1
IC1104
BE
C1103
16
CL2131
CL2132
4 5
CL508
CL510
R1254
C
R2101
CL2128 CL2130
192
R1159
193
C1706
R1784
S2
G2
D1
C1120
C1121
C1122
C1123
C1124
8
CL2127
C1705 C1704
C1802
R1801
1
Q1701
CL2129
L1801
R1125
R1126
G
Q1105 S
3
1
R1744
R1783 3
1
D
1
RB1105
1
R2177
C2130
R1135
D1802
D1801
C1801
3 4
1 5
R1752
R1742
L1704
RB1106
27
C1725
R1757
IC1703 IC1702
4
5
19
1
L1701
L1702
L1703
C1703
C1727
9
R1748
3
4
1
5
C1730
C1729
R1754
CN504
CN1701
HDMI OUT
C1728
IC1707
B
10
(NC)
MAIN BOARD (COMPONENT SIDE)
CL509
9
R567
R566
R565
R564
A
2
: Uses unleaded solder.
C515
R532
R529
R527
1
R1747
6-5.
1
19
C510
(CHASSIS)
R1237
11, 12
1-877-065-
G
OPTICAL PICK-UP
BLOCK
(KHM-313CAB)
(1/2)
(11, 12)
DISPLAY BOARD
CN803
(Page 32)
• Semiconductor Location
Ref. No.
Location
D501
D502
D505
D693
D1801
D1802
D9712
B-8
D-9
C-9
B-9
B-2
B-2
C-6
IC501
C-8
Ref. No.
IC503
IC692
IC1101
IC1102
IC1103
IC1104
IC1105
IC1107
IC1110
Location
B-8
B-9
C-4
C-6
B-6
B-5
C-3
D-3
D-3
Ref. No.
Location
IC1201
IC1702
IC1703
IC1705
IC1707
IC1901
D-6
B-2
B-2
B-4
B-4
C-2
Q503
Q1101
B-8
E-5
Ref. No.
Q1102
Q1103
Q1105
Q1701
Q9724
Q9726
Q9728
Q9729
Location
E-3
E-5
B-4
B-4
C-6
C-6
C-6
C-6
Note: IC1103 cannot exchange with single. When this part
is damaged, exchange the entire mounted board.
SCD-XA5400ES
22
22
SCD-XA5400ES
PRINTED WIRING BOARDS - MAIN Section (2/2) - • See page 21 for Circuit Boards Location. •
1
2
4
5
J691
(US, CND)
MULTI
MAIN BOARD (CONDUCTOR SIDE)
2CH
R1753
R570
JL620 JL622
JL625
JL621 JL623
2
R692
FB1113
R1781
R1153
JL501
IC506
6
JL597
JL600
JL596
JL599
IC504
R1205
R2152
C1128
R2156
R1103
R2157
JL1113
R2159
C1127
FB1117
C2503
FB1116
6
IC505
C1176
R2155
C2117
C2116
R1213
R579
JL538
R580 FB508 FB505
FB510 C538
JL627
JL644 JL643
CL1211
CL1209
CL1210
JL1211
1
6
CN1202
11
7
CN1201
1
JL1201 JL1202 JL1204 JL1205
JL573
JL557 JL546
JL1107
JL1108
JL1109
JL1110
R582
JL1210
JL628
1
JL1208
JL1209
C579
R1232
R1234
JL2152
C2118
JL1212
C1199
JL2162
C1169
JL2144
6
JL2121
JL2122
JL2123
JL2124
1
R1186
C2110
CN1801
(NC)
R1128
JL2145
JL2147 JL2139 JL2148
JL2146
JL2143
JL2142 JL2140 JL2149
JL2150
JL2135 JL2137 JL2138
JL2141
JL2163 JL2164 JL2125
JL2126
JL2136 JL2133 JL2134
FB1109
C1151
C1130
C1140 R1141
C1165
C1146
R1132
C1149
C1129
C2109
C1159 R2134
R2178
JL1130
FB1112
JL1131
JL1136
R1101
(NC)
JL1111
JL1112
JL1203 JL1213
JL1206
JL2161
C2108
FB1107
JL2153
CN1105
JL1207
C578
C580
C583
JL578 JL645JL646 JL647 JL648 JL649 JL650
5
C577
C582
C584
1
CL1212
JL575
C593
C581
JL642
C594
JL537 JL549 JL560 JL567
JL534
C592
5 JL638
1
R540
C591
JL551 JL565 JL569
5 JL626
1
JL541 JL554 JL563 JL570
C1154
C1114
C527 JL630
C528
R1175
C2502 C1172
C1163
C1125
R571 JL629
JL508
FB2101
R1782 C1108
C1175
C1161
C2119
C1174
FB1118
C1158
JL2151
R1140 R1133
C1109
C1156
C1160
R2184 C1171
R2180
C1144
R2185
C1170
C1155
R2150 R1148 R1152
R2119
R1145
R2151 R1147
R2160 R2158
R592
6
R1730
R1154
R1155
R9922
JL564
JL568
JL576
JL581
JL585
JL589
JL592
JL595
JL593
R9918
C2100
R1198
R558
C518
C526
JL500
JL506
E
JL616
JL617
JL514
R574
JL510
JL504
JL503
JL502
JL582
JL586
JL574
JL580
JL584
JL588
JL591
JL594
C507
JL527
JL525
JL523
JL521
JL519
JL535
JL531
JL539
JL544
JL550
JL555
JL561
C
R517
C517 R539
JL615
JL613
JL611
JL609
JL607
JL605
JL603
JL601
JL614
JL612
JL610
JL608
JL606
JL604
JL602
JL598
JL542
JL547
JL552
JL558
JL562
JL566
JL571
JL579
JL583
JL587
JL590
JL517
JL528
JL526
JL524
JL522
JL520
JL518
C508
C1162
C1702
R1702
C1701
FB2103
JL2130
JL545 JL553JL559
JL529
JL516
JL515
C1164
R1106
R1105
JL533
JL530
C503
C502
C501
JL572
JL532
JL536
JL543
JL548
JL556
C1177
R581
C2115
IC693
JL511
L1705
4
1
3
IC1701
R1701
EB502
3
1
R560
R2200
C1181
C2114
B
C1191
2
R1751
R1749
R1750
C1180
C1179
JL624
JL619
JL509
S501
OFF
ON
OPTICAL
JL1701
(CHASSIS)
D691
JL618
JL507
10
DIGITAL OUT (CD)
COAXIAL
C1197
JL505
9
J1701
MDMI PRIORITY
R691
D
8
1
D692
7
S502
IR REMOTE
IN
D692
REMOTE
CONTROL
TRANSMITTER
6
FB1115
A
3
: Uses unleaded solder.
C1126
C1116
C1115
6-6.
JL2106 JL2110 JL2114 JL2118
JL2102
JL2104
JL2108 JL2112 JL2116 JL2120
JL2103
JL2107 JL2111 JL2115 JL2119
JL2101
JL2117
JL2105 JL2109 JL2113
JL1132
JL1133
JL1134
JL1135
C1106
R2129
EB501
CN506
11, 12
1-877-065-
F
POWER BOARD
CN104
F
MOTOR BOARD
CL015
1
2
CL016
CN012
1 2
CN011
SW011
(DISC IN/OUT)
M001
(LOADING)
• Semiconductor
Location
CL010
1
CN010
M
11
G
1-877-109-
(11)
5
CL011
SW010
(CHUCKING)
CL014
CL012
CL013
1-877-108-
SCD-XA5400ES
(CHASSIS)
OPTICAL PICK-UP
BLOCK
(KHM-313CAB)
(2/2)
(Page 37)
OUT SW BOARD
(11, 12)
23
11
(11)
23
Ref. No.
Location
D691
D692
B-2
B-1
IC504
IC505
IC506
IC693
IC1701
D-4
D-3
D-3
B-2
B-9
SCD-XA5400ES
6-7.
SCHEMATIC DIAGRAM - MAIN Section (1/4) -
1
2
3
4
5
6
7
8
9
10
11
12
13
14
MAIN BOARD (1/4)
REG01
A
IOPMON
1
IOP
MAIN
BOARD
(3/4)
100k
R1223
100k
REG02
FCS-
FCS-
FCS+
VREFO
R1221
56k
R1226
56k
C1211
0.033
R1232
18k
R1220
1k
SPFG
CL1207
CL1206
C1214
1000p
TRK+
TRK-
TRK-
C1221
0.1
SPFCSSP+
CL1209
4.6
9.2
9.2
1.7
2.9
2.9
1.4
5
0
2.1
2
1.4
48 47 46 45 44 43
JL1204
42 41 40 39 38 37
FIN
1.4
1.4
1.4
TRO
R1209
33k
2
MAIN
BOARD
(3/4)
(Page 26)
R1204
1.2k
C1206
220p
C1203
0.01
R1215
12k
1.4
CL1202
R1207
2.7k
3.2
CL1203
R1205
2.2
1.4
10k
1.4
FMO
E
3.2
R1210
47k
C1208
0.01
R1216
12k
1.4
CL1204
1.4
1
36
2
35
3
34
4
33
5
32
6
31
FIN
CL1201
R1206
10k
D
JL1205
SL+
JL1206
7
30
8
29
9
28
10
27
11
26
12
25
4.4
CL1210
FCS+
4.5
CL1211
TRK+
4.5
CL1212
TRK-
3
SP+
4
LIMIT
5
(GND)LMIT
6
SL-
7
SL+
3.5
C1218
10
16V
C1219
0.01
REV
C1224
0.01
C1220
10
16V
FWD
JL1212
OCSW
JL1213
4.5
SL-
4.5
SL+
3.3
SP-
5.8
SP+
R1236
1k
CKSW
C1225
1000p
R1237
1k
JL1207
JL1208
JL1210
R1243
47
4.5
9.2
3.2
3.2
3.2
3.2
3.2
3.2
0
1
1.4
19 20 21 22 23 24
FIN
JL1211
6
OCSW
5
CKSW
4
GND
3
LDM-
2
NC
1
LDM+
C1223
0.1
OCSW1
D-GND
R1224
10k
C1213
0.01
M+9V
R1254
10k
DMO
(Page 25)
5V
CL1205
R1219
27k
5
MAIN
BOARD
(2/4)
CN1202
6P
C1226
1000p
4.8
F
3
(1/2)
4.9
JL1209
13 14 15 16 17 18
MAIN
BOARD
(3/4)
OPTICAL
PICK-UP
BLOCK
(KHM-313CAB)
R1246
4.7k
R1213
6.8k
G
(Page 26)
C1222
0.1
1.4
FIN
R1214
15k
NC
SL-
FOO
C1205
220p
SP-
2
JL1203
FOCUS/TRACKING COIL DRIVE
SPINDLE/SLED/LOADING MOTOR DRIVE
IC1201
FAN8036L
R1208
33k
R1247
1k
CN1201
7P
JL1201
1
JL1202
IC1201
C
4
MAIN
BOARD
(3/4)
LIMITSW
R1233
33k
C1212
0.01
R1212
10k
FCS+
TRK+
R1234
10k
CL1208
B
C1209
0.033
R1231
15k
C1233
4700p
RF+3.3V
R1230
82k
(Page 26)
CL1213
R1225
C1215
0.01
C1217
47
16V
R1238
1k
R1239
1k
M-GND
C1210
0.01
6
MAIN
BOARD
(2/4)
(Page 25)
D3.3V
R1229
12k
MUTE123
TSD_M
MUTE
8
MAIN
BOARD
(4/4)
(Page 26)
(Page 27)
MOTOR BOARD
H
CN010
5P
M001
(LOADING)
OUT-SW BOARD
CL010
M
CL011
CL012
SW011
(DISC IN/OUT)
CL013
CN012
2P
I
CN011
2P
CL015
CL016
SCD-XA5400ES
24
24
1
OSCW
2
GND
GND
1
OCSW
2
SW010
(CHUCKING)
CL014
1
LDM+
2
LDM-
3
GND
4
CKSW
5
OCSW
SCD-XA5400ES
6-8.
SCHEMATIC DIAGRAM - MAIN Section (2/4) 1
3
2
4
• See page 38 for waveforms.
5
6
• See page 38 for IC Block Diagrams. • See page 41 for IC Pin Function Description.
7
9
8
10
11
12
13
15
14
16
17
18
MAIN BOARD (2/4)
19
CN506
11P
R579
100
A
JL645
JL646
R580
100
JL647
SA/CD
MU/ST
34
DVD_SCO
33
99
AVCC
DVD_SOD
32
100
No Use
DVD_SID
31
No Use
R694
10k
IC692
XSYSRST
JL609
XIFCS
3.2 (2.8)
JL610
3.2 (2.8)
JL611
2.2
JL612
3.3
JL613
IFSCK
0.1
JL614
IFSDO
0.4 (∗)
JL615
R602
100
XIFBSY
R601
100
10k
R518
10k
R519
10k
JL617
10k
JL616
C693
2.2
50V
R587
10k
IC B/D
C515
0.1
RESET SIGNAL GENERATOR
IC503
PST3635NR
CL507
3.2
0
3.2
C520
0.22
R562
47k
C692 (US,CND)
0.1
R556
47k
R696
100
1
OUT
2
VDD
3
GND
CD
NC
5
R508
0
R697
100
R517
10k
CL504
R515
10k
R516
10k
R561
100k
C521
0.01
C523
0.1
IC B/D
VOUT
GND
VIN
VCONT
4
5V
5
4
3
2
1
D-GND
D3.3V
5V
R586
1k
M+9V
3.6
4
C522
0.22
R585
68k
R583
10k
R584
12k
L
JL578
G
DISPLAY
BOARD
CN803
(Page
33)
M
SCD-XA5400ES
2
LED_PAUSE
3
LED_HDMI
4
NC
5
EN_A
6
NC
7
EN_B
8
D-GND
9
KEY2
10
E+4V
11
KEY1
12
SIRCS
13
OCSW1
KEY0
14
D-GND(FL)
15
P_CONT1
16
FL_CS
17
FL_DATA
18
FL_CLK
19
IFSCK
IFSDO
STT_M/2
DMUTE
EN_A
XIFBSY
EN_B
XSYSRST
JL565
DMUTE
IFSCK
IFSDO
IFSDI
XIFBSY
XIFCS
JL563
JL560
100
JL549
C510
XIFCS
R564
100
JL618
KEY1
RESET
SIRCS
CNVSS
R565
KEY0
IFSDO
R566
IFSCK
R567
0.1
100
100
100
JL619
JL620
JL621
JL622
JL541
JL538
R533
100
FL_CS
JL537
R535
100
FL_DATA
JL534
R530
100
FL_CLK
10
MAIN
BOARD
(4/4)
11
MAIN
BOARD
(4/4)
(Page 27)
12
MAIN
BOARD
(3/4)
(Page 26)
XSYSRST
KEY2
R526
(Page 24)
CN504
9P
JL557
JL554
MAIN
BOARD
(1/4)
CEC_RX_IN
STT_D/P
IFSDI
JL567
6
CEC_TX_OUT
STT_D/P
LED_HDMI
(Page 26)
(Page 27)
R581 100
CEC_TX_OUT
LED_PAUSE
JL546
M+9V
STT_M/2
JL569
MAIN
BOARD
(3/4)
D3.3V
CEC_RX_IN
JL573
7
+6V
E3.3V
JL570
(Page 27)
D-GND
JL627
LED_PLAY
JL551
M-GND
JL626
JL575
MAIN
BOARD
(4/4)
C580
100
16V
OCSW1SIG
OCSW1SIG
FL_DATA
FL_CS
CEC_TX_OUT
FL_CLK
RESET
EN_B
EN_A
CNVSS
SIRCS
CEC_RX_IN
CN502
19P
1
5V
JL638
C577
0.01
9
D-GND
D3.3V
ASDMUTE
LED_LAT
E
D3.3V
D501
MA2J1110GLS0
CL515
LED_PLAY
E
D-GND
JL628
J
K
FB508
3.2
C584
100
10V
C579
100
16V
(AEP)
(US,CND)
C581
0.01
6
0
IC503
R527
10k
R588
33k
R592
0
IC504
SI-3010KM-TLS
X501
5MHz
C508
0.1
SENSE
R589
6.8k
+9V REGULATOR
Q503
2SC3052EF-T1-LEF
RESET SWITCH
CL505
1
IC504
R536
0
3.2
2
DAC_CLK
R563
10k
R557
47k
IC B/D
3
C583
100
10V
DAC_DATA
CL506
IC692
TC7W53FK(TE85R)
4
R590
1k
0.01
4
5
IC B/D
IFSDI
R520
10k
3
C592
0.01
+5V REGULATOR
IC505
SI-3010KM-TLS
C578
2
C594
100
10V
6
IC505
REV
FWD
R582
A
GND
CH1
R531
10k
SIRCS SELECT SWITCH
1
R528
10k
R538
1M
5
VEE
CH0
6
INH
I
7
COM
VCC
8
C517
0.1
3.3
0.9
JL608
3.3 (3)
DAC_DATA
R539
H
D693
MA2J1110GLS0
R695
100k
R693
100k
C591
0.01
JL607
3.2 (3)
0
0
3.2
JL606
3.2
JL594
JL591
0
JL586
0
2.8
2.6
JL584
JL582
JL580
0
3.2
XIN
3.2
3
JL577
JL574
CL502
1k
R532
CL503
JL559
JL556
JL553
1k
R529
CL516
JL536
DAC_CLK
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
3.3
9
No Use
8
FL_D_OUT
7
FL_STB
6
FL_CLK
5
AC_CU0
4
ASDMUTE
3
No Use
2
NMI
1
VCC1
R514
10k
R596
10k
10k
R501
1M
CL517
FB505
E
DVD_XIFBUSY
VREF
3.1
R559
JL605
JL642
KEY0
98
1
M-GND
R598
1.5k
R597
22k
VCONT
97
C507
0.1
1
(Page
35)
3.2
35
STT_D/P
VCONT
FWD
STT_M/2
JL603
VIN
AVSS
DMUTE
JL602
3.3 (0)
GND
96
JL601
0
5.9
36
JL588
NC
10k
VIN
REV
0
R521
GND
KEY1
JL572
M10V
2
R551 100
C593
100 10V
XAMUTE
No Use
XDOUT_EN
No Use
No Use
No Use
No Use
VCC2
No Use
95
CL518
D505
MC2836
No Use
37
R512
10k
JL530
D_GND
3
3.2
JL595
3.2
0
3.3 (0)
JL585
JL583
JL581
3.2
JL579
JL576
JL566
JL564
JL562
JL561
JL558
JL555
JL552
JL568
VSS
No Use
No Use
No Use
No Use
No Use
No Use
No Use
No Use
No Use
DVD XIFCS
JL598 R558 10k
10.1
JL593
0
JL592
0
JL589
JL587
JL547
3
JL550
JL544
No Use
KEY_INT
KEY2
JL532
C503
0.1
38
1.6
R570
47k
R560
47k
39
MTK RST
VSS
2CH
C691
47
10V
40
P_CONT1
MODEL
EN_A
C502
0.1
3.2
P_CONT2
DESTINATION
CNVss
MULTI
R692
10
R510
10k
3.3
LED_HDMI
XOUT
C501
0.1
HDMI
PRUORITY
1
3.2
R513
1k
41
JL597
3.3 (0)
VOUT
JL529
KEY0
P_CONT0
JL596
0 (3.3)
SENSE
1k
94
D_GND
4
R599
1k
0
JL604
1
5
3.3 (2.7)
R511
42
2
0
JL517
KEY1
100
93
44
3
VOUT
3.3 (2.7)
R509
92
45
4
SENSE
JL516
KEY2
91
46
43
IC501
R5F3640DDFAR
5
F
POWER
BOARD
CN104
(CHASSIS)
5
9
0
No Use
DMUTE
STT_M2
No Use
RESET
10k
47
0.1
3.3
CL501
48
R650
100
10k
0
CL500
JL515
LED_PAUSE
JL600
STT_D/P
0
R506
S502
G
JL528
JL514
90
49
I2C_CLK
SYSTEM CONTROLLER
1.7
10k
LED_PLAY
EN_B
R504
0
DAC_CS1
89
No Use
C582
LED_PAUSE
88
D6V
IC B/D
R522
10k
R540
3.2
MULTI/STEREO
JL526
JL527
CDM_OPEN_SW
LED_PLAY
50
JL599
I2C_DATA
IC501
TROPENPWM
3.2
MULTI_PRIO
JL525
CEC_TX_OUT
DAC_CS1
R523
10k
SA-CD/CD
BYTE
2
DAC_CS2
D4V
6
IC506
No Use
3
CL510
VCC
GND
F
OUT
REMOTE CONTROL
RECEIVER
IC693
NJL23H400A
DAC_CS3
87
JL523
3.2 (0)
0
ON
DAC_INT
86
JL524
OFF
IC693
85
DAC_CS2
LED_HDMI
DIGITAL
OUT (CD)
OCSW
3.2
0
S501
CKSW
84
3.3
JL522
D4V
6
EB501
+3.3V REGULATOR
IC506
SI-3010KM-TLS
JL629
No Use
D691
MA2J1110GLS0
R691
10k
83
JL520
P_CONT0
7
EB502
JL590
No Use
J691
No Use
JL521
R544
10k
CL509
82
DAC_INIT
OCSW
D692
SID307BRTP19
REMOTE CONTROL
TRANSMITTER
No Use
0
CKSW
81
JL519
0.2
CKSW
OCSW
JL518
LED_LAT
R543
10k
REV
REV
IR REMOTE
IN
JL571
E4V
8
EB503
C531
0.1
R574
0
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
FWD
MAIN
BOARD
(1/4)
JL531
R603
0
R542
10k
FWD
(US,CND)
E
SCL
JL548
(Page 24)
SDA
JL545
5
JL510
JL511
JL539
13
JL535
DGND
ASDMUTE
3.2
12
CL519
3.2
11
SCL
DAC_CS2
JL509
JL542
10
SDA
DAC_CS1
JL508
C533
0.1
D502
MC2836
R534
10k
JL543
ASDMUTE
DAC_CLK
JL507
No Use
9
JL506
JL643
P_CONT1
9
C528
1000
6.3V
C518
0.1
R525
10k
PLL-IC_ISC_SCL
8
DAC_CS2
MU/ST
DAC_INIT
DAC_DATA
PLL-IC_I2C_SDA
DAC_CS1
CL514
JL505
SIRCS_IN
7
JL503
JL504
C527
2200
6.3V
C526
100
10V
JL630
CEC_RX_IN
6
DAC_CLK
SA/CD
1.8
DAC_DATA
XAMUTE
No Use
5
CL512
CL513
No Use
4
C538
1000p
CL511
JL501
JL502
No Use
MU/ST
DAC_INIT
R546
10k
R545
10k
R524
10k
0
D
3
JL650
JL644
JL533
(Page
30)
SA/CD
CL508
0
C
2
R604
B
AUDIO
BOARD
(1/2)
CN152
1
JL649
FB510
JL500
DGND
XAMUTE
XAMUTE
SCL
CN501
13P
CKSW
OCSW
B
SDA
JL648
11
10
XIFBSY
R568
IFSDI
R569
100
100
JL623
JL624
JL625
25
25
1
D-GND
2
RESET
3
CNVSS
4
RXD1
5
CLK1
6
E3.3V
7
RTS1
8
TXD1
9
D-GND
(NC)
SCD-XA5400ES
6-9.
SCHEMATIC DIAGRAM - MAIN Section (3/4) 1
2
3
4
5
• See page 38 for IC Block Diagrams. • See page 41 for IC Pin Function Description.
8
7
6
9
10
11
13
12
14
15
16
17
19
18
20
22
21
MAIN BOARD (3/4)
C1135
0.033
20
19
18
17
16
15
C1145
10
16V
C2108
4.7
C1165
0.1
14
13
11
A
12
MAIN
13 BOARD
(Page 27)
(4/4)
R2180
10k
VREFO
C1125
0.1
RF+3.3V
FB1112
6
∗
R2155
10k
+3.3V REGULATOR
5V
FB2101
1.2
1.2
FS
VREF
DACVDDC
VBUS_OE
VBUS_OC
SCORE/DIR_XSTATE
SPBCK
SPMCK
SPLRCK
ADIN(SPDATA)
ACLK
ABCK
ALRCK
MC_DATA(ADIN)
DVDD3
NO_USE
WIDE
RGB_SEL/DSEL
DVDD18
TRG_SW
KMOD
XVOICE/DIR_CSFLAG
SPDIF
APLLVSS
APLLCAP
APLLVDD3
ADACVSS2
DIR_CE
ASDATA3
ADACVSS1
ASDATA2
AVCM
DIR_CL
ASDATA1
ASDATA0
ADACVDD1
Rt/DIR_DI
Lt/DIR_DO
ADACVDD2
ADACVSS3
ADACVDD3
RFGND18
SADCVSS18
SADCVDD18
XTALO
RFVDD18
XTALI
JITFN
JITFO
PLLVSS
LPFON
PLLVDD3
LPFIP
LPFIN
LPFOP
RFVDD3
ADCVSS
ADCVDD3
RFRPDC
HRFZC
RFRPAC
RA0 140
54 MSW
RA10 139
55 DVDD18
BA1 138
56 HA2
BA0 137
57 HA3
_RCS 136
58 HA4
_RAS 135
59 HA5
_CAS 134
60 HA6
_RWE 133
61 HA7
DQM1 132
62 HA8
DVDD3 131
63 HA18
TSD_M 130
64 HA19
RD8 129
23
24
0
25
1.8
0
26
0
27
0
28
0
29
1.8
C1172
0.1
0
30
0
31
0
C2502
5600p
3.3
32
3.3
C1108
0.1
R1730
2.7k
1.4
0
33
3.2
34
1.8
C1109
0.1
1.6
35
3.3
R2184
100
3.3
3.3
0 (1.7)
36
1.4
37
2 (1.4)
38
1.2 (1.6)
39
0
40
0
41
0
42
3.3
43
1.6
44
3.3
C1176
0.01
1.3
45
1.3
46
1.8
C1162
0.01
1.8
47
0.4
49
1.2
51
3.1
53
3.3
54
3.3
55
2.8
56
3.3
R1781
3.3k
R1140
1k
0.1
0.1
0.1
0
0 (0.5)
0
0.1
0 (1.3)
0.1
0.1
0.1
1.3
3.3
1.8
0
1.3
3.3
2.8
3.3
3.2
3.2
3.2
3.2
∗
3.2
3.3
0
2.8 (2.4)
CL2101
3.3
∗
∗
∗
0
∗
∗
∗
∗
∗
1.8
CL2102
0
R2177
0.01
0
C1160
62
63
64
65
R2151
3.3k
R2152
3.3k
C1158
0.01
C1177
470
10V
FB1106
100
RB1113
0
RD0
RD1
RD2
RD3
RD4
RD5
RD6
RD7
DQMO
RB1112
0
R1156
10k
R2160
A17
C1144
0.01
HD7
A0
0
R2176
A21
HD6
HD5
HD4
HD0
R2150
3.3k
C1155
0.01
XRD
XROMCS
HD3
A1
XWR
HD2
A2
A2
A3
A4
A5
A6
A7
A8
A18
A19
A21
A20
A9
A10
A11
A12
61
R2115
3.2
IC1102
66
67
68
69
R1135
1k
C2100
0.01
A14
0
5
R1155
SDA
0
GND
R1154
4
0
6
R1153
SCL
0
A2
R1152
3
3.2
C1136
0.01
FLASH ROM
IC1102
S29AL032D70TF-SCD-0801
A13
57
C2119
1000p
60
3.2
HD1
A3
R1106
10k
A15
C1164
0.01
JL2130
0.1
59
0
7
0
WE
0
A1
R1193
1k
R1191
1k
FB1111
70
71
72
C2130
0.01
73
3
MUTE
R1198
100
Q
MAIN
12 BOARD
(2/4)
(Page 25)
26
26
XIFBSY
XSYSRST
IFSDI
IFSCK
XIFCS
IFSDO
R2185
100
SCD-XA5400ES
(Page
27)
52
3.3
58
R2119
2
MAIN
BOARD
(4/4)
50
1.5 (1.2)
3.2
14
48
0.1
3.2
R1148
8
R1147
VCC
0
A0
R1105
10k
A16
22
0
A0
A4
24
P
CL1123 CL1160
R1145
1
2.1
A5
23
∗
A6
22
2.2
A7
21
∗
A17
20
∗
A18
19
∗
RY/BY
18
∗
N.C.
17
∗
N.C.
16
∗
RESET
15
3.2
WE
14
3.2
N.C
13
3.2
A19
12
3.2
A8
11
0
A9
10
∗
A10
9
∗
8
∗
7
∗
6
∗
5
∗
4
0.6 (∗)
3
0.1
2
0.7 (∗)
1
O
∗
3.3
A1
XROMCS
1.9 (∗)
25
CE
∗
0
26
VSS
27
OE
∗
∗
0
28
DQ0
29
DQ8
30
DQ1
31
A11
DQ2
32
DQ9
33
DQ10
34
DQ3
35
A12
DQ4
36
DQ11
37
A13
DQ5
∗
3.2
∗
38
A14
DQ6
39
VCC
∗
40
DQ12
∗
41
DQ13
42
DQ14
43
CL1121
IC1103
XWR
HD0
XRD
HD1
HD2
HD3
HD4
HD5
HD6
A0
HD7
∗
∗
VSS
DQ15/A-1
44
A15
A16
45
DQ7
∗
46
BYTE
47
21
EEPROM
S-24CS64A01-J8T1G
IC1103
M
48
FB1118
JL2162
3.3
0
JL2144
JL2145
JL2146
JL2147
JL2139
JL2161
JL2142
JL2143
0
0
3.3
0
0
0
0
JL2148
JL2151
JL2149
JL2150
JL2135
JL2137
1.8
1.7
0
0
3.3
JL2163
1.6
JL2126
1.6
JL2133
3.3
0
3.3
1.6
FB1107
1.8
1.8
0.5
1.4
1.8
3.3
1.8
1.6
1.8
1.6
3.3
3.3
1.8
1.4
1.4
1.7
3.3
680k
CL2118
C1138
R1141
100k
1000p
R1132
FB1109
R1782
3.3k
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128
C1110
1
N
R1175
0
FB1116
A17
L
CL2130
RD9
∗
53 LIMITSW
RD10
∗
A19
RA1 141
RD11
A8
A18
52 DIR_AUDIO/NC
RD12
IC1105
IC1105
TK11133CSCL-G
IC B/D
FB1115
R2133
0
5
∗
DVDD18 142
RD13
5
VIN
A7
RA2 143
51 DIR_ERROR/NC
RD14
CONT
∗
50 USB_VSS
RD15
GND
1
∗
A6
RA3 144
RD0
NOISE VOUT 4
2
∗
A5
49 USB_VDD18
RD1
(Page 25)
3
A4
DVDD3 145
RD2
3.3
D3.3V
3.3
∗
DRCLK 146
48 PAD_VRT
DVDD3
7
1.3
C1186
0.22
R1151
10k
2.1
A3
47 USB_VSS
DVDD3
C1182
0.22
C1184
0.01
A2
CKE 147
RD3
C1113
0.01
R1114
100k
46 USB_VDD3
RD4
C1127
0.01
R2129
100k
D-GND
MAIN
BOARD
(2/4)
0
3.3 (0)
1.8
C1106
0.01
K
CL1110
CL2109
DVSS 148
RD5
R1139
0
45 USB_DM
RD6
CD_LD
Q1102-1
AUTOMATIC POWER
CONTROL (CD)
RA11 149
RD7
FOO
0 (1.9)
44 USB_DP
EEWP
DVD_LD
RA9 150
DQM0
TRO
43 AVDD18
∗
FOO
Q1102-2
AUTOMATIC POWER
CONTROL (SA-CD) 0.1 (2.5)
FMO
TRO
-1
0
RA8 151
0
(Page 24)
DMO
-2
0
R1137
10k
R1138
10k
2.1 (2.4)
42 AGND18
1.9 (∗)
FMO
DMO
CL2104
3.6 (3.1)
2 (3.4)
2.5 (3.3)
RA7 152
A1
2
MAIN
BOARD
(1/4)
Q1102
QST8TR
R1107
10k
1.8
41 FOO
xIFBSY
CL1107
0.8
RA6 153
RESERVED
IOP
JL1113
R1103
5.1k
C2117
10
40 TRO
xSYSRST
R1123
0
RA5 154
ICE
R1124
47k
RA4 155
39 IOPMON
TXD
C1112
47
10V
DVDD3 156
38 TROPENPWM
RXD
R1121
22
R1120
22
37 FMO
OCSW
R1118
22
MUTE123 157
CKSW
R1115
22
R1113
22
R1112
22
R1110
47k
MUTE 158
36 DMO
SDA
C1105
47
10V
R1109
0
3.3
35 OP_INP
SCL
REG02
CL2155
DDC_DA 159
IFSDI
CL1106
CL2154
34 OP_INN
xIFCS
IOPMON
SPFG
1.8
HTPLG 162
DVDD18 160
IFCK
1.4
33 OP_OUT
IFSDO
FOO
AGND3 163
DDC_CLK 161
IC1101
CXD9927R
DVDD3
1.4
C2118
0.1
C2116
0.1
C2114
0.1
C2115
10
CL2103
1.7
TRO
IC1101
RF AMP, SERVO DSP, HDMI TRANSMITTER
32 TEZISLV
REV
1.4
EXT_RES 164
FWD
1.4
LIMITSW
J
1.4
CL1108
(Page 24)
I
31 TEO
FMO
AVDD3 165
29 VREFO
30 FEO
DMO
AVDD3 166
28 V2O
DVDD18
CL1301
27 V2REFO
CL1304
1.2
1.7
3.3
AGND18 169
HA0
R1108
1M
TXCN 170
HA17
MAIN
BOARD
(1/4)
C1199
4700p
TXCP 171
23 SVDD3
CL1303
CL1105
R1101
100
22 LDO1
EXT_CAP 167
FB1117
3.3 (0)
Q1103
RT1N241C-TP-1
INVERTER
CL1302
AVDD18 172
DVSS
R1111
100
21 LDO2
HD7
4
TX0N 173
0
H
TX0P 174
20 MDI2
AGND3 168
1.7
C2503 4.7
19 MDI1
26 SGND
1.5
C1126 0.1
AGND18 175
25 RFLVL
2.7
C1119
47
10V
4.7 (0.1)
18 TPI
CL1305
2.1
R1116
1k
TX1N 176
24 CSO
0
Q1101-1
CD ON SWITCH
TX1P 177
17 TNI
CL1101
C1117
47
10V
C1118
47
10V
16 SB
RESERVED
D1
AVDD18 178
HA21
S1
R1117
47k
2.8 (0)
15 SA
HD6
0.1 (0)
FCS-
FCS-
G2
TX2N 179
HD5
FCS+
FCS+
G1
TX2P 180
14 MD
HD4
TRK+
TRK+
S2
13 MC
HD3
4.7 (0.1)
0.1 (0)
D2
3.3
C1114
0.1
AGND18 181
HD2
TRK-
TRK-
2.1 (2.4)
Q1101-2
SA-CD ON SWITCH
Q1101
UM6K1N-TN
R/CR/PR 182
DVSS
FCS-
2.5 (3.3)
CL2129
0.2
CL2132
11 MA
12 MB
HD1
JL2124
2.1
CL2128
CL2131
HD0
FCS+
2.1
3.3
189
B/CB/PB 183
XRD
TRK+
JL2123
2.1
C1116
0.1
TRK-
JL2122
VOF
DACVSSA 184
HA1
JL2121
2.1
DVDD
XROMCS
VOC
JL2153
VOE
9
C1174
0.01
CL2127
191
10 DVDRFIP
HA20
VOD
CL1118
0
G
1.7
2.1
DVDC
Y/G 185
HA9
24
1.7
8
Y
DACVDDB 190
DACVSSB 188
∗
23
FCS-
1.7
1
DACVDDA 186
A20
FCS+
1
C1124
CVBS 187
DVDB
HA10
22
C1123
DACVSSC 192
DVDA
HA11
TRK+
VOD
2.1
C1115
0.1
C1161
0.01
AGND
HA12
21
1.7
JL2152
JL2120
C1175
0.01
R2101
560
7
∗
20
TRK-
1
JL2117
CL1117
JL2140
6
∗
VOC/C
F
C1122
VOA
JL2119
JL2138
JL2141
5
∗
19
VOC
2.1
JL2118
JL2125 JL2164
10k
VOD/D
1.7
10k
18
1.7
1
10k
17
VOB
CL1116
C1156
0.01
R2159
RF
(LO:DVD.HI:CD)MSW
CL1115
JL2136
C
R2158
16
1
C1121
2.1
JL2116
JL2134
AVDD3
R2157
VOA/A
C1120
VOB
JL2113
JL2115
C1151
1000p
C1148
0.047
4
A9
15
VOA
CL1113
VOF
C1171
0.1
FB2103
IREF
A10
14
VOB/B
VOE
JL2111
CL1114
C1169
0.1
C1163
0.01
RFGC
A11
VOF/F+H
JL2109
JL2114
R1159
10k
OSN
∗
13
C2110
1000
6.3V
R1160
47
3
10k
12
JL2108
CL1112
R1161
47
R1143
47
R2187
47
2
R2156
VC
GND (PDIC)
JL2107
JL2112
3.3
R1136
15k
CD_LD
JL2110
C1170
1500p
R1146
47
1
A12
11
0.9
JL2105
HA13
10
VCC
1.3
JL2104
∗
VOE/E+G
1.5
C1132
0.1
JL2103
A13
9
C1183
0.33
HA14
NC
R1185
47
256 255 254 253 252 251 250 249 248 247 246 245 244 243 242 241 240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193
HA15
8
R1186
10k
C2109
1000
6.3V
CL2119
C1195
0.22
R2178
1k
0.6 (∗)
7
C1187
180
6.3V
DVD_LD
JL2106
C1147
0.047
R2134
0
1.8
0.7 (∗)
6
VR (780)
2
O
G
3
A14
LD (780)
VR (650)
I
C1192
0.01
A15
5
VIN
C1198
1
OSP
PD
1
CRTPLP
4
IC1110
MM1661JTRE
1.3
RFGND18
3
NC
C1133
0.1
0.1
(2/2)
2
NC
C1154
0.1
C1149
0.1
C1146
0.1
C1139
22p
C1137
0.1
3.3
E
OPTICAL
PICK-UP
BLOCK
(KHM-313CAB)
LD (650)
JL2102
C1140
0.1
HA16
C1193
0.22
C1101
0.01
C1159
0.1
A16
D
1
3
3.3
JL2101
GND (LD)
2
3.2
R1102
0
CN1101
24P
1
IC1110
+1.8V REGULATOR
REG01
C
4
NOISE VOUT
IC B/D
C1129
10
3.3
5
GND
IC1107
+3.3V REGULATOR
IC1107
TK11133CSCL-G
(Page 24)
C1111
180
6.3V
XWR
1
MAIN
BOARD
(1/4)
CONT
B
C1130
0.1
MUTE123
MAIN
BOARD
(1/4)
(Page 24)
Note: IC1103 cannot exchange with single. When this part
is damaged, exchange the entire mounted board.
SCD-XA5400ES
6-10. SCHEMATIC DIAGRAM - MAIN Section (4/4) 1
2
3
• See page 38 for IC Block Diagrams.
5
4
7
6
8
10
9
12
11
13
14
15
17
16
18
MAIN BOARD (4/4)
MAIN
BOARD
(2/4)
DMUTE
STT_M/2
CN1110
13P
13
JL1135
CL1166
JL1136
CL1167
9
10
11
12
CL1168
R1142
100
1.6
1Y
0
1
1Z
CL1165
2
0Y
0
1.6
JL1134
3
13
14
15
16
19
IC1901
TC74LVX4053FT(EL)
20
IC1701
TOTX147L(RED)
3.3
IC B/D
3.3
IC1703
TC7S08FU(TE85R)
C1705 0.1
22
23
24
1
0 (1.4)
1
0 (1.4)
VCC 5
4
GND
3.3
5
VCC
2
3
3.3
0 (1.4)
4
GND
1
0 (1.4)
6
VCC
IN
3
J1701
1P
4
L1705
D3.3V
C1701
47p
C1704
0.1
27
29
30
1
4
2
3
(Page 25)
31
L1702
RA9
41
RA11
0
CLKE
3.3
RA11
42
1.6
CLKE
43
(Page 26)
0
RA8
40
14
RA9
R2114
22
RB1104
0
2.8 (2.4)
DQM1
RA3
45
RB1108
0
RA1
47
RD8
RA0
48
RB1103
0
3.3
RD10
RD11
BA1
50
0.1
RD9
RA10
49
0.1
0.1
BA0
51
RCS
52
RAS
53
CAS
54
RWE
55
DQM1
56
RB1111
0
R1133
0
57
A5
A2
25
31
A6
A1
24
32
A7
A0
23
33
A8
A10
22
A9
BA1 21
35 A11
BA0 20
36 NC
/CS
34
0.1
RB1107
0
0
RD12
RD13
3.3
RD14
0 (0.5)
RD15
0
/RAS 18
38 CLK
/CAS 17
39 UDQM
41 VSS
VDD 14
42 DQ8
DQ7 13
43 VDDQ
44 DQ9
RB1109
0
58
RD9
59
46 VSSQ
VDDQ 9
48 DQ12
49 VDDQ
50 DQ13
51 DQ14
53 DQ15
RD11
61
63
L
64
65
RB1110
0
1.3
RA2
1.8
RA1
0.4
DQ4
8
DQ3
7
DQ1
4
VDDQ 3
DQ0
2
VDD 1
C1191
0.1
TMDS DATA2+
TMDS DATA2 SHIELD
TMDS DATA2-
2
3
4
TMDS DATA1+
5
TMDS DATA1 SHIELD
6
TMDS DATA1-
7
0.1
TMDS DATA0+
RA10
1.2
BA1
1.5 (1.2)
BA0
3.1
RCS
3.3
RAS
3.3
CAS
3.3
RWE
2.8
DQMO
3.3
1.3
9
TMDS DATA0-
2
3
10
TMDS CLOCK+
11
TMDS CLOCK SHIELD
12
TMDS CLOCK-
13
CEC
14
Reserved
15
SCL
16
SDA
17
DOC/CEC GND
18
+5 POWER
19
HPD
R9945
220
R1783
0
3.3
RD7
LEVEL SHIFT
RD6
IC1705
TC7SZ08FU(TE85R)
RD4
0
R1748
0
R1749
1.8k
R1750
1.8k
R1751
0
5
R9941
27k
2
R1752
0
Q9724,9726,9728,9729
CEC DATA SWITCH
4
1
1.8
JL1701
R1746
0
R1747
R1784
0
RD5
0
TMDS DATA0 SHIELD
4
CL1702
IC1705
RB1106
47
8
1
3.2
D9712
MA2J1110GLS0
3
3.3
2.7
Q9724
ISA1602AM1TP-1EF
Q9726
2SC4154TP-1EF
0.1
R9918
1k
Q9729
RT1N141C-TP-1
RB1105
47
R1744
4.7k
RD3
E3.3V
CEC_RX_IN
R9934
10k
R9935
0
R9920
0
0
0
1.3
0
0
1.6
Q9728
2SC4154TP-1EF 2.7
3
C1180
0.1
R9928
22k
R9924
1k
0
3.3
R9929
22k
C9972
0.1
R1753
0
R9922
10k
RD1
0.1
CEC_TX_OUT
RD0
R1754
0
0.1
3.3
3.2
0.1
3.3
3.3
C1190
180
6.3V
IC1104
+6V
Q1701
UM6K1N-TN
LEVEL SHIFT
C1179
0.1
S2
M+9V
D2
G2
G1
D1
S1
3.3
Q1105
2SK2009(TE85L)
B+ SWITCH
3.3
5
3.2
IC1707
+5V REGULATOR
IC1707
TK11150CSCL-G
S
IC B/D
9
IC1104
V54C365164VEI7
10
6
5
5
4
5
3
2
1
1.3
MAIN
BOARD
(2/4)
(Page 25)
0
R2200
10k
3.3
RD12
RD13
1
FB1108
C1725
0.01
RD14
R1742
47k
C1729
0.22
C1728
47
10V
C1730
0.22
C1727
0.01
RD15
D-GND
D3.3V
TSD_M
R1757
0
66
JL1107
68
JL1108
69
JL1109
70
JL1110
71
R2110
72
2.7k
JL1111
JL1112
73
SCD-XA5400ES
8
27
27
MAIN
BOARD
(2/4)
(Page 24)
CN1105
6P
67
M
(NC)
3
RD2
5
GND
2
RA0
VSSQ 6
DQ2
CVBS
4
4
L1704
3.3
NC
3
1
SD-RAM
RD10
60
62
RD8
C1181
0.1
DQ6 11
DQ5 10
47 DQ11
RA3
VSSQ 12
45 DQ10
54 VSS
K
/WE 16
LDQM 15
52 VSSQ
0 (1.3)
19
37 CKE
40 NC
RA2
46
30
1.3
VIN
RB1115
0
0
RA8
RA7
39
MAIN
BOARD
(3/4)
RA4
RA6
38
1.2 (1.6)
RA7
RA5
37
2 (1.4)
26
5V
2
HDMI
OUT
L1703
CONT
36
RA6
A3
1
CN1701
19P
GND
RB1114
0
1.4
A4
D1801
MA2J1110GLS0
NOISE VOUT
R1785
0
RA5
29
3
VDD
35
0 (1.7)
2
VSS
R1786
0
3.3
4
D1802
MA2J1110GLS0
C1801
47p
C1197
0.1
0
RA4
34
VDD 27
1
L1801
2.2uH
C1802
47p
R1801
75
3.3
28 VSS
33
44
MAIN
BOARD
(2/4)
5V
FB1113
J
C1703
0.1
CN1801
4P
32
I
C1706
180
6.3V
L1701
28
H
9
D-GND
26
G
DIGITAL
OUT (CD)
COAXIAL
25
F
OPTICAL
GND
R1701
75
2
IC1702
TC7S08FU(TE85R)
2
3
3
LEVEL SHIFT
LEVEL SHIFT
3.3
1
0 (1.4) 2
IC1702
IC1703
2
E
(Page 26)
18
MULTIPLEXER
21
D
17
OPTICAL TRANSMITTER
IC1901
22
27M
4
MAIN
BOARD
(3/4)
16
R1702
12
5
C1702 1
11
GND
6
VCC
10
7
IC1701
R1128
47
3.3
GND
SDTR
8
YCOM
9
CL1164
1.6
SDTL
JL1133
ZCOM
8
15
1X
7
CL1163
XCOM
6
PDT
GND
13
14
JL1132
0Z
GND
13
C1103
0.1
INH
5
12
0X
SBCK
47
VEE
4
R1125
A
3
GND
CL1162
(Page 25)
11
GND
PLRCK
JL1131
47
B
2
R1126
C
(Page
30)
1
GND
CL1161
3.3
A
AUDIO
BOARD
(1/2)
CN151
PBCK
JL1130
3.3
B
C
11
STT_D/P
A
1
TXD
2
RXD
3
GND
4
+3.3V
5
V2REFO
6
RFMON
(NC)
SCD-XA5400ES
Location
F-3
F-5
B-7
F-3
E-4
E-4
F-6
E-5
D-5
C-5
D-3
E-5
D-6
D-8
E-8
E-3
Q151
Q291
Q292
E-9
E-8
E-8
1
2
3
4
•
: Uses unleaded solder.
5
6
7
8
10
A
AUDIO BOARD (COMPONENT SIDE)
EE153
IC153
5 4
(CHASSIS)
CL218
C179
CL219
B
C177
C181
1 3
C180
CL168
CL167
CL166
JW150
CL271
CL220
CL222
C218
CL221
C219
CL223
1
8
4
5
CL273
C216
CL217
IC204
C
C226
C227
1
C229
C276
8
CL212
CL213
4
CL200
5
4
5
IC255
8
CN152
5
IC253
CL183
CL181
CL182
R152
B
R171
C160
C155
R173
R174
C183
9
CL152
16
R151 FB151
1
1
8
IC156
C158 C157
3
CL185
CL189
CL153
1
IC151
CL188
CL154
C151
8
C172
4
CL190
CL186
1
FB153
4
FB152
CL170
R161
CL171
4
R155
1
CL202
R153
C256
CL162
C255
C164
CL174
IC152
5
1
CL173
CL180
14CL179
CL177
CL172
C152
C153
15
IC202
R160
R162
C154
28
CL163
8
CL175
CL176
C163
4
5
C292
R169
R168
R167
R166
3
1
IC201
Q292
1
(Page 22)
C162
C161
E B
CL169
CL192
R159
E B R185 R184
Q151
CL157
CL201
CL165
CL164
IC291
C291
EE152
5
R293
R288
8
Q291
B E
CL191
C176
11, 12
CL155
1-0877-066-
R158
28
4
R299
R289
C182
(CHASSIS)
28
C168
CL193
C205
CL156
R154
IC154
C206
MAIN BOARD
CN501
CL151
R201
R182
C159
4
5
CL160
CL161
X151
CL159
C156
CL187
R181
C171
C174 1
1 3
R157
R156
IC206
8 5
9
C210
C207
R150
C173
E
16
CL158
C208
CL184
R183
5
5 4
(CHASSIS)
1
4
C264
C209
IC292 IC155
8
F
8
IC203
(Page 22)
C175
EE151
C263
2
CL195 CL197
13
12
2
1
R180
R179
R178
R177
R176
R175
CL215
CL214
C214
1
CL199
CL194 CL196 CL198
A
MAIN
BOARD
CN1110
C213
C281
8
1
IC205
CN151
C277
C279
C231
5
4
D
CL272
C271
C221
CL216
SCD-XA5400ES
9
12
13
IC151
IC152
IC153
IC154
IC155
IC156
IC201
IC202
IC203
IC204
IC205
IC206
IC253
IC255
IC291
IC292
• See page 21 for Circuit Boards Location.
1
Ref. No.
6-11. PRINTED WIRING BOARD - AUDIO Section (1/2) -
CL178
• Semiconductor
Location
(11, 12)
SCD-XA5400ES
6-12. PRINTED WIRING BOARDS - AUDIO Section (2/2) - • See page 21 for Circuit Boards Location. •
SCD-XA5400ES
: Uses unleaded solder.
29
29
SCD-XA5400ES
6-13. SCHEMATIC DIAGRAM - AUDIO Section (1/2) - • See page 38 for waveforms.
1
3
2
4
5
• See page 38 for IC Block Diagrams.
6
7
9
8
10
11
12
13
14
15
AUDIO BOARD (1/2)
R150
22
(Page 35)
C157
0.1
CN151
13P
C158
0.1
C183
180
6.3V
C156
180
6.3V
C152
0.1
R171
10k
R174
10k
C154
18p
4
SDTL
5
GND
6
PDT
7
R175
22
CL195
R176
22
GND
8
SBCK
9
GND
10
PLRCK
11
GND
12
PBCK
13
CL196
R177
22
CL197
CL198
CL199
R178
R179
MAIN
BOARD
(2/4)
CN501
I
3
ASDMUTE
4
SBCLK_INI
5
DAC_CS1
6
DAC_CLK
7
DAC_DATA
8
R180
J
1.2
5
IC206
IC201
SWITCHING
R182
22
3.3
IC201
NJM2870F33(TE2)
VDD 8
1
2
7
3
6
4
GND
1
2
3
+3.3V REGULATOR
IC206
TC7W08FU(TE12R)
1.7
CL154
5
3.3
IC B/D
1.7
5
R181
22
3.3
5
4
3.3
3.3
1.7
CL183
CL182
QA
QB
QC
QD
ENT
LOAD
B
C
D
ENP
GND
1
5
9
SA/CD
11
XAMUTE
12
DGND
13
CL170
1.7
R161
22
CL171
1.7
R162
22
CL172
0
R163
22
CL173
0
R164
22
CL174
0
R165
22
CL175
0
CL176
1.7
1.7
3.3
CL165
10
C205
39
16V
IC202
R160
22
3.3
3.3
CL164
MU/ST
C206
0.1
CL157
R166
100
CL177
3.2
R167
100
CL178
0
R168
100
CL179
3.2
R169
100
CL180
3
VCC2L 28
1
DSDL
2
DSDR AGND3L 27
3
DBCK
4
PLRCK IOUTL+ 25
5
PDATA AGND2 24
6
PBCK
7
SCK
8
DGND VCOMR 21
9
VDD
IOUTL- 26
VCC1 23
VCOML 22
IREF 20
10 MS
AGND1 19
11 MDI
IOUTR- 18
12 MC
IOUTR+ 17
C207
0.1
5
0
0
C208
39
16V
5
3.3
3.3
C209
180
6.3V
C210
0.1
2.5
R201
10k
0
0
13 MDO AGND3R 16
CL151
14 RST
VCC2R 15
5
C256
0.1
CL158
C171
0.1
CL201
C161
0.1
C163
180
6.3V
C164
0.1
C169
470p
C170
0.1
CN154
3P
D
POWER
BOARD
CN105
8
D/A CONVERTER
IC202
DSD1796DBR
22
CL153
DAC_INIT
(Page 25)
7
3
C162
0.1
E
B
2
6
6
22
CN152
13P
SCL
5
2
22
1.6
SDA
4
IC B/D
(CHASSIS)
1
3
8
C176
0.001
EE152
DGND
2
7
C182
470p
H
9
CL156
NB
GND
CL194
VOUT
G
3
CTL
(Page 27)
2
10
4
CL159
GND
A
MAIN
BOARD
(4/4)
CN1110
GND
SDTR
11
C172
0.1
VIN
F
1
12
X151
22.5792MHz
CL200
27M
13
A
1.7
IC B/D
R154
1M
14
1
COUNTER
IC156
SN74LV161APWR
4
R155
100
C151
0.1
R173
10k
3
CL184
CK
3.4
2
1.6
1
15
CARRY
OUTPUT
3.3
GND
FB153
16
VCC
VCC
IC156
CL181
1.7
1.7
3.3
1.7
5
IC152
TC7WU04F(TE12R)
1.7
VOUT
NB
VIN
GND
3
6
3.3
2
2
IC152
7
1.6
CL_GND
1
8
C153
15p
3.3
POWER
BOARD
CN105
1
5
R153
330
CLOCK BUFFER
C160
470p
E
CL5V
C159
39
16V
4
CTL
+3.3V REGULATOR
IC154
TK11131CSCL-G (US,CND)
NJM2870F33(TE2) (AEP)
5
R183
22
R158
100
3.3
5
IC154
D
CL160
CL188
C174
0.1
CL155
C155
470p
IC B/D
CN156
2P
IC B/D
FB152
11
E
3.3
4
CLR
E
(CHASSIS)
Q
GND
3
IC155
TC7W74FU(TE12R)
CL161
CL202
R157
22
C175
0.001
3.2
2
E
C
CLR
Q
1
C173
0.1
EE151
3.3
D
3
1.6
VDD
8
CL186
IC155
CL189
2
CL190
A1
7
5
D-FILP FLOP
1.7
6
6
CLK
1
7
GND
IC292
TC7SZ04FU(TE85R)
8
PR
VCC
INVERTER
NC
NC
IPRG
4
3.3
5
9
0
4
10
XOUT
VSS
1.6
NC
REF
3
0
XIN
VDD
VSS
2
0
A0
CLKP
11
R156
22
C177
0.001
EE153
12
1
0
IC B/D
13
SDA
IC151
FS7140-01G
14
1.7
5
IC292
CL185
SCL
CLOCK GENERATOR
15
0
IC151
B
16
CLKN
CL187
1.7
3.3
R152
22
3.3
FB151
VCC
R151
150
2.2
CL152
A
CL162
DAC5V
1
NC
2
DAC_GND
3
CL163
C165
470
16V
C255
39
16V
(Page 35)
K
SCD-XA5400ES
30
30
11
AUDIO
BOARD
(2/2)
(Page 31)
SCD-XA5400ES
6-14. SCHEMATIC DIAGRAM - AUDIO Section (2/2) 1
3
2
4
• See page 38 for IC Block Diagrams.
5
6
7
9
8
10
11
12
13
15
14
AUDIO BOARD (2/2)
A
R202
680
1/3W
CL212
C211
4700p
100V
JW150
R222
560
1/3W
C228
47
100V
C223
1500p
100V
R223
680
1/3W
R224
560
1/3W
(US,CND)
C222
0.015
100V
C214
0.1
VCC
7
5
6
0
-2.3
0
2.7
2
C224
0.015
100V
8
C212
4700p
100V
CL213
R203
680 1/3W
CL214
R253
680 1/3W
D
3
1
7
1
R206
560
1/3W
R209
560
1/3W
3.3
C217
1500p
100V
CL193
VOUT
VIN
3
2
1
12.1
R254
560
1/3W
IC153
TK11133CSCL-G
IC B/D
C180
0.1
C218
0.1
-1.2
VCC
C219
0.1
R261
220k
1/3W
CL192
C295
470
10V
R184
10k
R289
100
ANALOG OUT
UNBALANCED
8
R255
680
1/3W
R256
560
1/3W
J251
1P
R
C266
1500p
100V
C270
47
100V
C271
0.1
R260
220
1/3W
C273
1500p
100V
C278
47
100V
C279
0.1
R278
220
1/3W
R274
560
1/3W
R262
10
1/3W
-11.8
R295
470k
C292
0.1
C167
220
25V
-2.3
0
5
4
1
VEE
C274
0.015
100V
6
0
VEE
2
7
D252
MA2J1110GLS0
Q253
DTC114EKA-T146
RELAY DRIVE
VCC
C166
220
25V
3
-2.3
C291
0.1
12.1
12.1
5
R294
470k
Q252
DTA114EKA
RELAY DRIVE
9.3
-8.5
-11.8
IC255
LOW-PASS FILTER
IC255
NJM2114M-TE2
R279
220k
1/3W
C276
0.1
R282
220k
1/3W
C277
0.1
C297
4.7
50V
R292
47k
CL272
R280
10
1/3W
C254
0.001
C252
0.047
J252
4P
RY252
+
8
1
2
R
3
R275
560
1/3W
-11.8
3
0.2
0.2
1.9
2
0.2
1
0.1
C200
0.047
RY201
+
C282
470p
-11.8
6
VCC
7
R212
10
1/3W
D201
MA2J1110GLS0
R211
220k
1/3W
J201
1P
L
-11.8
CL219
C272
0.015
100V
LINE AMP
+
RY291
C168
0.1
7
IC204
OPA2132UA/2K5
R291
47k
0.1
0.2
0.2
8
IC291
R185
10k
IC291
NJM2043M-D-TE2
J
IC204
(AEP)
CL218
(AEP)
R293
100
12.1
I
Q151
DTC114EKA-T146
RELAY CONTROL
1
12.1
C232
470P
Q204
DTC114EKA-T146
RELAY DRIVE
0
-1.2
-1.2
-1.2
R259
560
1/3W
6
4
R159
10k
2
C267
1500p
100V
R272
560
1/3W
R288
100
9.3
Q201
DTA114EKA
RELAY DRIVE
9.3
CL220
12.1
12.1
C294
470
10V
C293
0.047
R210
220
1/3W
CL217
C179
0.1
C296
4.7
50V
CL191
D291
MA2J1110GLS0
C221
0.1
C265
8200p
100V
IC153
Q291
DTA114EKA
RELAY DRIVE
-8.5
C220
47
100V
R233
10
1/3W
12.1
H
R231
220
1/3W
BUFFER
R273
680
1/3W
C181
10
16V
L
12.1
1.3
Q292
DTC114EKA-T146
RELAY DRIVE
-11.8
-11.8
2
+3.3V REGULATOR
CONT
G
5
GND
3.3
3
0
R258
680
1/3W
R257
560
1/3W
12.1
4
NOISE
Q293
DTA114EKA
RELAY CONTROL
C231
0.1
-11.8
5
8
3.3
C230
47
100V
-8.5
7
0
C216
1500p
100V
-11.8
R252
680 1/3W
R213
10k
1
3
VEE
R208
680
1/3W
CL215
5
6
R232
220k
1/3W
J202
4P
CL223
4
C262
4700p
100V
4
R205
680
1/3W
8
2
3
C227
0.1
C204
0.001
C201
0.047
RY202
+
12.1
R207
560
1/3W
C264
0.1
VCC
7
1
IC205
NJM2114M-TE2
C225
1500p
100V
R226
680
1/3W
12.1
6
0
5
-2.3
E
R230
10
1/3W
D202
MA2J1110GLS0
R229
220k
1/3W
C226
0.1
C215
8200p
100V
C263
0.1
BUFFER
IC253
OPA2132UA/2K5
CL169
20
CL216
-2.3
0
-11.8
2
12.1
R227
560
1/3W
R225
560
1/3W
R204
560
1/3W
VEE
IC253
3
Q202
DTA114EKA
RELAY DRIVE
9.3
8
C261
4700p
100V
4
IC205
LOW-PASS FILTER
12.1
6
C
(Page
30)
19
-11.8
Q203
DTC114EKA-T146
RELAY DRIVE
VCC
VEE
IC203
OPA2132UA/2K5
0
-11.8
4
1
2.8
2
C213
0.1
5
R228
220
1/3W
12.1
3
BUFFER
11
18
12.1
VEE
4
IC203
AUDIO
BOARD
(1/2)
17
-8.5
-11.8
-2.3
0
-11.8
B
C229
0.1
JW150 0
(AEP)
F
16
CL222
CL273
R276
680
1/3W
R277
560
1/3W
C275
1500p
100V
C280
47
100V
C281
0.1
R281
220
1/3W
R283
10
1/3W
CL221
R299
100
CN155
5P
CL167
CL168
CL271
K
1
A+12V
2
NC
3
AGND
4
A-12V
5
ASDMUTE
CN291
4P
1
L
HP BOARD
CL166
C
C819
0.1
J801
PHONES
RV801
1k
PHONE LEVEL
POWER
BOARD
CN105
(CHASSIS)
C802
0.001
L803
(Page 35)
-1
CN801
4P
GND
RCH
4
LCH
3
2
NC
3
L
NC
2
4
R
GND
1
CL905
CL804
L802
-2
CL802
CL904
L801
CL801
SCD-XA5400ES
31
31
C801
0.001
SCD-XA5400ES
Location
3
4
•
5
: Uses unleaded solder.
6
7
8
9
10
11
DISPLAY BOARD
G
B
MAIN
BOARD
CN502
(Page 22)
CL886
CL884
JW830
CL887
CL918
JW829
CL825
6
3
59
JW826
JW828
CL885
CL879
JW825
CL878
C813
C
Q802
1
JW802
JW801
JW806
JW807
JW810
JW811
JW804
JW805
R804
CL811
CL839
32
CL822
JW812
JW813
JW814
R812
1
3
C804
4
C803
1
ND801
FLUORESCENT INDICATOR TUBE
CL819
5
55
CN805
D801
CL893
CL815
1
CL898
CL814
CL920
CLP801
IC801
1
CL817
CL877
CN802
H
IC802
C818
R810
5
4
C812
CL919
CL916
R811
33
JW823
JW803
CL881
JW824
CL829
JW808
JW835
C811
C810
1
64
CL826
JW809
JW833 JW831 JW834
CL880
3
R807
R808
R809
JW815
IC803
C808
C807
C806
JW816
CL900
JW827 JW836
JW817
E-10
B-4
D-4
D-4
CL823
CL896 CL915 8
JW818
CN803
CL914
CL899
CL897
CL895
CN804 CL894
JW819
CL917
1
JW820
A
B E
Q801
Q802
Q803
Q804
• See page 21 for Circuit Boards Location.
CL876
CL875
CL874
CL873
CL872
CL871
CL870
CL869
CL868
CL867
CL866
CL865
CL864
CL863
CL862
CL861
CL860
CL859
CL858
CL857
CL856
CL855
CL854
CL853
CL852
CL851
CL850
CL849
CL848
CL847
CL846
CL845
CL844
CL843
CL842
CL841
CL840
CL838
CL837
CL836
CL835
CL834
CL833
CL832
CL831
CL830
CL828
CL827
CL824
CL821
CL820
B-10
A-5
B-3
2
2
IC801
IC802
IC803
1
JW832
A-10
C-3
C-4
1
D801
D802
D803
19
Ref. No.
6-15. PRINTED WIRING BOARDS - PANEL Section -
18
• Semiconductor
Location
POWER BOARD
CN103
11
1-877-069-
(Page 37)
LED BOARD
D802
/
D803
9
C815
C814
JW852
JW853
JW851
11
1-877-072-
(11)
KEY-R BOARD
KEY-L BOARD
R817
D
Q804
E B
R816
Q803
E B
1
CL883
CN806
8
CL911 CL913
CL890
R815 CL892
S810
S809
S808
JW856
CL882 CL910 CL912 CL888
R814 CL891
9
Y
S807
C805
S805
R805
/
"
CL889 R813
E
HDMI JW857
S804
S803
R803 CL810
CL816
R802 CL807
MULTI/2CH
TIME/TEXT
S801
CL818
Q801
R806
B E
CL902
JW855
CL903
CL901
1
1-877-071-
S801, 807 – 810
11
1-877-070-
(11)
S802 – 804
JOG BOARD
3
CLP805
1
S806
F
S806
ROTARY ENCODER
C816
4
CN808
1
CL906
4
5
AMS
PUSH ENTER
C817
CL907
CL908
CLP806
CL909
11
1-877-073-
SCD-XA5400ES
CL803
4 CN809 1
11
G
S802
R801
SA-CD/CD
CN807
4
(11)
32
32
(11)
S805
(11)
SCD-XA5400ES
6-16. SCHEMATIC DIAGRAM - DISPLAY Board -
1
2
• See page 38 for waveforms.
3
4
• See page 38 for IC Block Diagrams.
5
6
7
8
9
10
11
12
13
14
CN805
4P
DISPLAY BOARD
A
1
FL_G
2
FL6V
3
KEY0
4
LED_HDMI
(Page 34)
AD1
S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
-24.4
-20.6
-22.5
-18.8
-24.4
-24.3
-24.3
-24.3
-24.3
-20.7
-24.3
-26.2
-26.2
-24.4
-20.6
-26.2
-24.4
-20.8
-18.8
-26.2
-24.4
-22.5
-26.2
-24.4
-24.4
-20.6
-26.2
-26.2
31
CL880
32
IC803
S28
S27
30
S26
S24
S22
29
S25
28
27
S23
26
25
S21
24
S20
23
S19
22
S18
21
S17
20
S16
19
S15
18
S14
17
S13
S10
16
15
S12
14
S11
13
S9
12
S8
11
S7
10
S6
S4
S3
9
S5
8
7
S2
6
S1
AD1
P2
AD2
P1
5
CN802
6P
CL879
CL881
IC B/D
CL919
G1
S35
S34
S33
S32
S31
S30
S29
43
42
41
40
39
38
37
36
35
34
33
CL839
0
-22.5
CL815
-22.6
1.4
CL814
IC803
NJM2870F33(TE2)
6
3.3
E
VOUT
1
GND
2
NB
3
6
CL900
C810
47p
S29
S30
S31
S32
S33
S34
S35
G2
G3
G4
C811
10
16V
Q802
DTC114EKA-T146
GRID DRIVE
3.3
CL899
CL897
CL896
CL894
R812
100k
CL893
C806
470p
C807
470p
C808
470p
CL920
R809
100
CL915
R808
100
CL887
R807
100
CL886
C818
0.1
CL916
CL885
CL884
ND801
FLUORESCENT INDICATOR TUBE
6
FL6V
5
FL-27
4
FL_G
3
FLAC4.3
2
NC
1
FLAC4.3
1
LED_LAT
2
LED_PLAY
3
LED_PAUSE
4
LED_HDMI
5
NC
6
EN_A
7
NC
8
EN_B
9
D_GND
H
POWER
BOARD
CN103
(Page
35)
CL914
1.2
CL895
G1
G5
G6
G7
G8
G9
G10
G11
G12
G13
G14
G15
CL829
CL826
CL823
R810
1k
4
CLT
CL918
CL898
-24.4
R811
3.3k
VIN
C813
0.1
C812
0.1
21
D
5
CL878
-24.4
G2
44
-24.4
G3
45
-18.8
G4
46
-18.8
G5
47
-24.5
G6
48
-24.6
G7
49
-24.5
G8
50
-24.5
G9
51
-24.5
G10
52
-24.5
G11
53
-24.5
G12
54
-24.5
G13
55
-24.5
G14
56
-24.5
G15
57
-24.5
G16
58
-24.5
VFL
59
-24.5
GND
60
-24.5
OSC0
61
-24.5
OSC1
62
-26.2
XRST
63
1.4
IC B/D
64
3.1
IC802
ML9208-03MBZ03B
XCS
+3.3V REGULATOR
3.3
C804
10
16V
4
2.9
C
FLUORESCENT
INDICATOR
TUBE DRIVER
3
CLK
C803
0.01
2
DAT
3.2
IC802
R804
47
D801
MA2J1110GLS0
1
0
CL811
CL819 CL822 CL825
VDD
GND
2
0
OUT
3
VCC
1
3.3
REMOTE CONTROL
RECEIVER
IC801
NJL24H400A
-20.6
IC801
B
M
KEY-L
BOARD
CN809
10
KEY2
11
E+4V
12
KEY1
13
SIRCS
14
KEY0
15
D_GND_FL
16
PCONT1
17
FL_CS
18
FL_DATA
19
FL_CLK
G
MAIN
BOARD
(2/4)
CN502
(Page
25)
CN803
19P
F
1
5
6
7
8
9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55
CN804
8P
59
SCD-XA5400ES
33
CL877
CL875
CL876
S1
S2
CL873
CL874
S3
S4
CL872
S5
CL870
CL871
S6
S7
CL869
S8
S9
CL868
CL867
S10
CL866
S11
CL865
33
S12
CL864
S13
CL863
S14
CL861
CL862
S15
S16
CL860
S17
CL858
CL859
S18
S19
CL857
S20
CL855
CL856
S21
S22
CL854
S23
S24
CL853
CL852
S25
CL850
CL851
S26
S27
CL849
S28
CL848
S29
CL846
CL847
S30
S31
CL845
S32
CL843
CL844
S33
S34
CL842
S35
CL840
CL841
AD1
G1
CL838
G2
G3
CL837
CL836
G4
CL834
CL835
G5
G6
CL833
G7
CL832
G8
CL831
G9
CL828
CL830
G10
G11
CL824
CL827
G12
G13
CL820
CL821
G14
G
G15
CL817
1
CL917
LED_PLAY
2
LED_PAUSE
3
FL6V
4
EN_A
5
EN_B
6
FL_GND
7
KEY2
8
KEY1
N
KEY-R
BOARD
CN806
(Page
34)
SCD-XA5400ES
6-17. SCHEMATIC DIAGRAM - KEY Section -
1
2
3
4
5
7
6
8
KEY-R BOARD
A
Q804
DTC114EKA-T146
LED DRIVE
Q803
DTC114EKA-T146
LED DRIVE
3.1
0
LED BOARD
4.6
0.2
JW852
R817
220
B
D802
SEL5521C-TP15
D803
SEL5821A-TP15
R816
150
JW851
CN806
8P
C814
0.1
C815
0.1
JOG BOARD
CL882
N
C
LED_PLAY
1
LED_PAUSE
2
FL6V
3
EN_A
4
DISPLAY
BOARD
CN804
EN_B
5
FL_GND
6
(Page 33)
KEY2
7
KEY1
JW853
CL883
CL911
CL912
CL913
CL888
C817 0.01
CN808
4P
CN807
4P
CL910
S807
S808
S809
S810
CL890
4
EN_A
KEY2_JOG
1
3
EN_B
GND
2
2
GND
EN_B
3
1
KEY2_JOG
EN_A
4
8
CL891
R813
1k
D
CL807
R801
1k
CL892
CL889
R802
2.2k
CL810
R803
2.2k
CL816
R805
4.7k
S805
HDMI
CN809
4P
CL902
CL818
SCD-XA5400ES
CL907
CL906
5
S801
I/
4.5
CL903
0
S804
SA-CD/CD
S802
TIME/TEXT
R806
150
S803
MULTI/2CH
Q801
DTC114EKA-T146
LED DRIVE
34
34
CL901
4
LED_HDMI
3
KEY0
2
LED6V
1
GND
M
DISPLAY
BOARD
CN805
(Page 33)
1
2
4
C805
0.1
F
CL908
AMS PUSH ENTER
R815
2.2k
KEY-L BOARD
CL803
C816 0.01
CL909
S806
ROTARY ENCODER
R814
1k
E
9
3
SCD-XA5400ES
6-18. SCHEMATIC DIAGRAM - POWER Board -
1
2
3
• See page 38 for IC Block Diagrams.
4
5
6
7
8
9
10
11
12
POWER BOARD
A
R106
22k
CN103
6P
CL102
B
H
DISPLAY
BOARD
CN802
(Page 33)
FLAC4.3
1
NC
2
FLAC4.3
3
FL_G
4
FL-27V
5
FL6V
6
R104
100
R105
100
D130
UDZS-TE17-5.1B
C112
0.01
C110
10
50V
R103
3.3k
C113
0.01
Q101
2SA1213Y-TE12L
-27V REGULATOR
CL104
-26.8
IC101
UPC2406AHF
CL105
6
O
2
I
G
STANDBY
BOARD
CN001
(Page 36)
NC
2
3
D_GND
4
E4V
5
D
OUT
2
VCC
IC102
F
D4V
8
D4V
7
MAIN
BOARD
(2/4)
CN506
D6V
6
D_GND
5
D_GND
4
M10V
3
NC
2
M_GND
1
CL108
CL109
+4V REGULATOR
IC103
BA00BC0WT-V5
5
4
3
2
1
IC B/D
D110
EC10QS04-TE12L5
CL125
R107
150k
CL113
CL114
C115
2200
16V
R108
68k
CL115
(Page
AUDIO BOARD
(1/2)
30)
CN154
(Page 31)
AUDIO BOARD
(2/2)
CN155
D
C
NC
2
3
DAC5V
4
DAC_GND
5
A+12V
6
A_GND
7
A-12V
8
ASDMUTE
9
6
P8
7
P8
8
M13
9
M13
8
AC4V1
7
AC4V2
6
AC6V1
5
AC6V2
4
AC15V1
J
MAIN POWER
TRANSFORMER
PT002
(Page 36)
O
I
G
1
OUT
2
IC104
CL117
CL118
C105
10000
16V
D118
EC10QS04-TE12L5
8.5
VCC
1
D124
EC10QS04-TE12L5
IC105
C106
2200
25V
+5V REGULATOR
D122
EC10QS04-TE12L5
CL119
D125
EC10QS04-TE12L5
IC106
KIA7812API-U/PF
CL121
12.1
CL132
2
O
I
G
CL128
1
D128
EC10QS04-TE12L5
IC106
C107
2200
35V
+12V REGULATOR
C119
2200
25V
-11.9
O
G
D126
EC10QS04-TE12L5
C108
2200
35V
IC107
3
2
CL129
-12V REGULATOR
I
D127
EC10QS04-TE12L5
16.7
C118
2200
25V
I
D123
EC10QS04-TE12L5
CL127
C117
2200
25V
CL120
CN102
8P
D121
EC10QS04-TE12L5
GND
3
CL116
TH101
D120
EC10QS04-TE12L5
+6V REGULATOR
5
TH102
D119
EC10QS04-TE12L5
CL126
3
1
-16
CL130
IC107
KIA7912PI
SCD-XA5400ES
FL30
D117
EC10QS04-TE12L5
8.5
IC105
BA05T
1
D114
EC10QS04-TE12L5
C104
10000
16V
CN105
9P
CL_GND
FL30
5
D116
EC10QS04-TE12L5
C116
2200
16V
E
FLAC4.3
4
D115
EC10QS04-TE12L5
CL101
3
(Page
3
D113
EC10QS04-TE12L5
CL112
2
CL5V
NC
D112
EC10QS04-TE12L5
5
5
1.2
CL111
3.8
CL110
6
AUDIO BOARD
(1/2)
30)
CN156
FLAC4.3
2
D109
EC10QS04-TE12L5
IC103
CL107
IC104
UPC2406AHF
G
1
D111
EC10QS04-TE12L5
CONT
9
C103
6800
25V
+10V REGULATOR
VI
P_CONT0
D106
EC10QS04-TE12L5
1
GND
GND
10
D108
EC10QS04-TE12L5
14
VO
E4V
CN101
9P
D102
EC10DS2-TE12L5
D105
EC10QS04-TE12L5
C102
1000
16V
CL131
CL124
F.B.
11
CL122
CL123
C111
0.01
D107
EC10QS04-TE12L5
IC101
C114
2200
25V
F
H
D104
EC10DS2-TE12L5
9.8
3
P_CONT1
(Page 25)
TH103
1
CN104
11P
E
D103
EC10DS2-TE12L5
1
ASDMUTE
D101
EC10DS2-TE12L5
(AEP)
IC102
BA10T
10
C101
100
63V
-35.4
+6V REGULATOR
CN106
5P
L
R101
10k
(US,CND) JW115
CL106
3
P_CONT0
R102
10k
CL103
C109
470
10V
C
D129
UDZSTE-1727B
35
35
3
AC-15V1
2
NC
1
ACG
K
MAIN POWER
TRANSFORMER
PT003
(Page 36)
SCD-XA5400ES
6-19. SCHEMATIC DIAGRAM - STANDBY Board -
1
2
• See page 38 for IC Block Diagrams.
3
4
5
6
7
8
9
10
STANDBY BOARD
F001
∗
11
∗F001,002
T800mAL 250V (US,CND)
T500mAL 250V (AEP)
12
VO
GND
VI
CONT
3
2
1
IC B/D
RY01
L1
2
NC
3
GND
1
L2
2
NC
3
GND
POWER
BOARD
CN101
PT003
MAIN POWER
TRANSFORMER
POWER
BOARD
CN102
R60
4.7
L
POWER
BOARD
CN106
1
NC
2
ASDMUTE
3
D_GND
4
E4V
5
D54
11EQS04-NTA2B
4
OUT
2
(Page 35)
C60
470
25V
C54
470p
D
IC51
BA05T
R56
150k
E
EE51
JL001
R57
68k
C57
470
25V
12.1
VCC
GND
1
3
C58
0.1
0
R54
2.2k
Q51
2SC1740S-QRT
R51
AC DETECT
10k
0.6
C51
10
50V
0
0
R52
6.8k
R53
22k
R55
10k
Q52
2SC1740S-QRT
RELAY DEIVE
D52
11EQS04-NTA2B
6
TH50
4
L51
10mH
7
C53
2200
25V
D55
11EQS04-NTA2B
D53
11EQS04-NTA2B
IC51
3
C56
0.056
C55
4700p
9
3
1
11
36
CN004
3P
1
2
+4V REGULATOR
36
2
8
10
(CHASSIS)
SCD-XA5400ES
5
R61
680
D57
1SS133T-72
C
P_CONT0
D56
1SS133T-72
T002
SUB POWER
TRANSFORMER
CN001
5P
C52
0.01
250V
4
C59
0.01
250V
1
L
2
NC
3
N
J
PT002
MAIN POWER
TRANSFORMER
D58
1SS133T-72
5
4
F.B
4
3.2
5
0
+3.2V REGULATOR
IC52
BA00BC0WT-V5
1
CN003
3P
F002
∗
B
(Page 35)
CN002
3P
A
IC52
13
AC IN
K
(Page 35)
SCD-XA5400ES
6-20. PRINTED WIRING BOARDS - POWER Section -
1
A
2
• See page 21 for Circuit Boards Location.
3
4
•
5
: Uses unleaded solder.
6
7
POWER BOARD
8
9
10
JW106
D128 D126 D125 D127
JW115
D129
Q101 C
R101
B
R106
D130
1 3
TH102
JW113
IC101
2
HT52
JW104
D111
D117
C108
C107
C106
D113
R61
TH50
C56
D55
(CHASSIS)
HT51
JL001
R51
D54
C54
D52
Q52
R60
C51
D53
T002
SUB POWER
TRANSFORMER
D58
R52
R53
5
11
D57
RY01
C109
C103
D115
CL124
D120
JW116
JW110
CL126
D118
CL128
1
B
D109
C104
C105
2 3
C57
E
D116
D119
JW103
CL129
IC52
C58
D56
R54 R55
D114
B
EE51
IC51
C55
CL127
JW112
E
5
R57
D112 D110
C113
Q51
C53
A101
C110
R103
TH101
JW107
R105
R104
E
(AEP)
C112
D122 D124 D123 D121
C111
CLP51
1
C60
CL123
4
R102
CLP104
C102
9
2
B
(US, CND)
CL122
TH103
CLP102
CN101
1
CL131
C101
CN001
JW51
1
8
5
R56
D108 D106 D105 D107
D102 D104 D103 D101
CN102
1
C
12
STANDBY BOARD
CLP101
CLP103
11
~AC IN
CL125
CL130
IC107
1
D
3
IC106
2
1 3
A107
CL101
IC105
2
1 3
A106
IC104
2
A105
JW102
IC102
1
1
A104
JW101
R108
2
A103
3
2
IC103
4
(US, CND)
4
1
E
C118
3
2
5
L51
JW114
JW117
CL132 CL121 CL120 CL119 CL118 CL117
CL116
CL109
CL115
1
9
CN106
5
1
CN105
CL108
CL107
1
CL106
CN103
F001
FH02
CL113
11
CL114
1
1
CL133
CN002
CN104
11
1-877-067AUDIO
BOARD
CN155
F
C
AUDIO
BOARD
CN154
D
(Page 29) (Page 29)
E
3
SCD-XA5400ES
Location
B-12
C-12
B-12
B-12
B-12
C-12
C-9
B-4
B-4
B-4
B-4
Ref. No.
D105
D106
D107
D108
D109
D110
D111
D112
D113
D114
D115
Location
B-6
B-5
B-6
B-5
C-5
C-5
C-5
C-5
C-5
C-5
C-5
F
(Page 29)
Ref. No.
D116
D117
D118
D119
D120
D121
D122
D123
D124
D125
D126
3
11
AUDIO
BOARD
CN156
MAIN BOARD
CN506
DISPLAY BOARD
CN802
(Page 23)
(Page 32)
H
1-877-068-
PT002
MAIN
POWER
TRANSFORMER
• Semiconductor Location
D52
D53
D54
D55
D56
D57
D58
D101
D102
D103
D104
1
CN003
(11)
PT003
MAIN
POWER
TRANSFORMER
Ref. No.
FH04
CLP105
CL110
CL112
F002
6
CL102 CL103
JW108
CL111
C59
C114
C115
JW105
C52
FH03
CL105
CL104
JW111
C116
3
JW54
A102
R107
C117
CN004
1
FH01
C119
1
Location
C-5
C-3
C-3
C-3
C-3
B-3
B-2
B-3
B-2
B-2
B-2
Ref. No.
Location
D127
D128
D129
D130
B-2
B-2
B-3
B-5
IC51
IC52
IC101
IC102
IC103
IC104
B-10
B-9
B-6
D-6
D-5
D-4
Ref. No.
Location
IC105
IC106
IC107
D-3
D-2
D-1
Q51
Q52
Q101
B-12
C-9
B-4
37
37
(11)
SCD-XA5400ES
• Waveforms
RB
XB
OX
A
B
C
IC802 UM (OSC1)
IX
IC152 X-COM
IC501 RE (XOUT)
16
15 14
13
12
11
10
9
OUT
2.9 Vp-p
632 ns
20 ns
1 V/DIV, 200 μs/DIV
1 V/DIV, 20 ns/DIV
2 V/DIV, 200 ns/DIV
CL1168 (27MHz)
C
OUT
IN
OUT
C
OUT
IN
C
IN
4
5
6
7
8
GND
3
Z-COM
2
IZ
1
OY
100 mV/DIV, 50 ns/DIV
IY
37 ns
VEE
C
OUT
IN
3.1 Vp-p
INH
3.9 Vp-p
1.4 Vp-p
200 μs
IN
C
LOGIC LEVEL CONVERTOR
OUT
IN
C
OZ
– DISPLAY Board –
Y-COM
– AUDIO Board –
– MAIN Board –
VCC
IC1901 TC74LVX4053FT (EL)
– AUDIO Board –
IC151 FS7140-01G
• IC Block Diagrams
– MAIN Board –
IC503 PST3635NR
SCL 1
SDA 2
IC504 – 506 SI-3010KM-TLS
OUT 1
5 CD
REGISTERS
ADDR0 3
VC 1
VDD 2
I2C
INTERFACE
LOOP
FILTER
VSS 4
VIN 2
XIN 5
XOUT 6
CRYSTAL
OSCILLATOR
REFERNCE
DIVIDER
(NR)
GND 3
ADDR1 7
–
+
VDD 8
–
+
4 NC
UP
VOLTAGE
CONTROLLED
OSCILLATOR
CHARGE
PUMP
DOWN
POST
DIVIDER
(NPX)
CMOS/PECL
OUTPUT
FEEDBACK
DIVIDER
(NF)
TSD
VREF
PHASEFREQUENCY
DETECTOR
16 CLKN
15 CLKP
14 VDD
13 N/C
12 REF
GND 3
REF
11 VSS
10 N/C
VOUT 4
9 IPRG
ADJ 5
IC1105, 1107 TK11133CSCL-G
IC1707 TK11150CSCL-G
VIN
VOUT
VIN
VOUT
8 VCC
VOUT
COMMON 1
IC153 TK11133CSCL-G
VIN
IC692 TC7W53FK (TE85R)
IC154 TK11131CSCL-G (US, Canadian models)
IC154 NJM2870F33 (TE2) (AEP model)
IC201 NJM2870F33 (TE2)
5
4
5
4
5
4
INH 2
OVER HEAT &
OVER CURRENT
PROTECTION
VEE 3
GND 4
LOGIC
LEVEL
CONVERTER
C
OUT
IN
7 CH 0
CONTROL
CIRCUIT
OVER HEAT &
OVER CURRENT
PROTECTION
CONTROL
CIRCUIT
–
+
THERMAL
PROTECTION
–
+
BANDGAP
REFERENCE
C
BANDGAP
REFERENCE
BANDGAP
REFERENCE
SCD-XA5400ES
38
GND
NP
1
2
3
NP
3
GND
2
VCONT
1
VCONT
5 A
38
1
2
3
NOISE
BYPASS
6 CH 1
GND
IN
CONTROL
OUT
SCD-XA5400ES
IC155 TC7W74FU
VCC
PR
CLR
Q
VCC
8
7
6
5
S
R
Q
D
Q
C
IC156 HD74LV161ATELL
16
15
14
13
12
11
10
RIPPLE
CARRY
OUTPUT
QA
QB
QC
QD
ENABLE
T
CLEAR
LOAD
4
GND
3
Q
2
D
CK
1
1
9
CK
A
B
C
D
ENABLE
P
2
3
4
5
6
7
8
GND
IC202 DSD1796DBR
28 VCC2L
27 AGND3L
POWER
SUPPLY
SYSTEM
CLOCK
MANAGER
DSDL 1
DSDR 2
DBCK 3
PLRCK 4
PDATA 5
PBCK 6
SCK 7
DGND 8
VDD 9
MS
MDI
MC
MDO
10
11
12
13
RST 14
CURRENT
SEGMENT
D/A
CONVERTER
AUDIO
DATA INPUT
INTERFACE
&
FUNCTION
CONTROL
INTERFACE
?8
OVERSAMPLING
DIGITAL FILTER
&
FUNCTION
CONTROL
26 IOUTL–
25 IOUTL+
24 AGND2
23 VCC1
ADVANCED
SEGMENT
D/A
CONVERTER
MODULATOR
BIAS
&
VREF
22 VCOML
21 VCOMR
20 IREF
19 AGND1
CURRENT
SEGMENT
D/A
CONVERTER
18 IOUTR–
17 IOUTR+
16 AGND3R
15 VCC2R
39
SCD-XA5400ES
– DISPLAY Board –
IC802 ML9208-03MBZ03B
64 VDD
8 BIT SHIFT
REGISTER
63 DA
62 CP
61 CS
60 RESET
P1 1
P2 2
PORT
DRIVER
AD2 3
AD
DRIVER
AD1 4
COMMAND
DECODER
CONTROL
CIRCUIT
ADRAM
16W × 2B
TIMING
GENERATOR2
CGRAM
248W × 35B
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
DCRAM
16W × 8B
TIMING
GENERATOR1
OSCILLATOR
59 OSC1
58 OSC0
57 GND
56 VFL
CGRAM
8W × 35B
ADDRESS
SELECTOR
READ
ADDRESS
COUNTER
WRITE
ADDRESS
COUNTER
DIGIT
CONTROL
GRID
DRIVER
SEGMENT
DRIVER
DUTY
CONTROL
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
COM16
COM15
COM14
COM13
COM12
COM11
COM10
COM9
COM8
COM7
COM6
COM5
COM4
COM3
COM2
COM1
39
38
37
36
35
34
33
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
– POWER Board –
IC103 BA00BC0WT-V5
VIN
VOUT
IC803 NJM2870F33 (TE2)
5
4
VCC
VREF
–
+
DRIVER
THERMAL
PROTECTION
3
VCC
GND
4
5
C
2
OUT
1
OCP
3
NOISE
BYPASS
2
GND
CONTROL
1
TSD
CTL
OVP
BANDGAP
REFERENCE
– STANDBY Board –
IC52 BA00BC0WT-V5
VCC
VREF
–
+
40
1
2
3
4
5
GND
OUT
C
OCP
VCC
TSD
CTL
OVP
DRIVER
SCD-XA5400ES
• IC Pin Function Description
MAIN BOARD IC501 R5F3640DDFAR (SYSTEM CONTROLLER)
Pin No.
1, 2
3
4
5 to 7
8
9
10
11
Pin Name
No Use
CEC_RX_IN
SIRCS_IN
No Use
BYTE
CNVSS
EN_A
EN_B
I/O
O
I
I
O
I
I
I
I
12
RESET
I
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49, 50
51
52
53
54
55
56
57 to 61
62
63
64
XOUT
VSS
XIN
VCC1
NMI
No Use
ASDMUTE
AC_CUT
FL_CLK
CEC_TX_OUT
FL_STB
FL_D_OUT
No Use
TROPENPWM
CDM_OPEN_SW
DAC_CLK
No Use
DAC_DATA
DVD_SID
DVD_SOD
DVD_SCO
DVD_XIFBUSY
FWD
REV
DVD_XIFCS
MTK RST
P_CONT1
P_CONT2
P_CONT0
No Use
STT_D/P
STT_M/2
DMUTE
No Use
I2C_DATA
I2C_CLK
No Use
Super Audio CD/CD
MULTI/STEREO
XAMUTE
No Use
DOUT_EN
MULTI_PRIO
No Use
VCC2
No Use
VSS
O
I
I
O
I
I
O
O
O
O
O
O
I
O
I
O
O
I
I
O
O
O
I
O
O
O
O
O
I
I
I
O
I/O
I
O
O
O
O
O
I
I
O
O
-
Description
Not used
CEC serial data input from the HDMI OUT connector
SIRCS signal input from the remote control receiver
Not used
External data bus width selection signal input terminal Fixed at "L" in this set
Processor mode switch input terminal
Jog dial pulse input from the rotary encoder (A phase input)
Jog dial pulse input from the rotary encoder (B phase input)
System reset signal input from the reset signal generator "L": reset
For several hundreds msec. after the power supply rises, "L" is input, then it change to "H"
Main system clock output terminal (5 MHz)
Ground terminal
Main system clock input terminal (5 MHz)
Power supply terminal (+3.3V)
Non-maskable interrupt input terminal Fixed at "H" in this set
Not used
AC detection signal input terminal
AC cut detection signal input terminal "L": AC cut on
Serial data transfer clock signal output to the fluorescent indicator tube driver
CEC serial data output to the HDMI OUT connector
Chip select signal output to the fluorescent indicator tube driver
Serial data output to the fluorescent indicator tube driver
Not used
Tray speed PWM control signal output terminal Not used
Disc insert (8/12cm) detect switch input terminal "L": disc insert
Serial data transfer clock signal output to the D/A converter
Not used
Serial data output to the D/A converter
Serial data output to the servo DSP
Serial data input from the servo DSP
Serial data transfer clock signal input from the servo DSP
Busy signal output to the servo DSP
Loading motor drive signal output terminal (forward direction)
Loading motor drive signal output terminal (reverse direction)
Chip select signal input from the servo DSP
Reset signal output to the servo DSP and flash memory "L": reset
Power on/off control signal output terminal "H": power on
Power on/off control signal output terminal Not used
Power on/off control signal output terminal "H": power on
Not used
Normal/squeeze selection signal input from servo DSP
Trigger detection switch input from the servo DSP
Audio muting signal input from the servo DSP
Not used
I2C Two-way data bus terminal Not used
I2C data transfer clock signal input terminal Not used
Not used
Not used
Not used
Relay control signal output terminal
Not used
Digital out (CD) On/Off signal input terminal
HDMI priority selection signal input terminal
Not used
Power supply terminal (+3.3V)
Not used
Ground terminal
41
SCD-XA5400ES
Pin No.
65 to 73
74
75
76
77
78
79 to 82
83
84
85
86
87
88
89
90
91
92
93
94, 95
96
97
98
99
100
42
Pin Name
No Use
KEY_INT
LED_LAT
No Use
PLL_IC_I2C_SDA
PLL_IC_I2C_SCL
No Use
CKSW
OCSW
DAC_INT
DAC_CS3
DAC_CS2
DAC_CS1
LED_PLAY
LED_PAUSE
LED_HDMI
DESTINATION
MODEL
KEY2, KEY1
AVSS
KEY0
VREF
AVCC
No Use
I/O
O
I
O
O
I/O
I/O
O
I
I
O
O
O
O
O
O
O
I
I
I
I
I
O
Description
Not used
Wake up signal input terminal
Serial data latch pulse signal output terminal Not used
Not used
I2C Two-way data bus with the clock generator
I2C data transfer clock signal input/output with the clock generator
Not used
Chucking detection switch input terminal
Disc table open/close detection switch input terminal
Reset signal output to the D/A converter "L": reset
Not used
Bit clock signal output to the d-flip flop
Chip select signal output to the D/A converter
Play LED drive signal output terminal "H": LED on
Pause LED drive signal output terminal "H": LED on
HDMI on/off LED drive signal output terminal "H": LED on
Setting terminal for the destination
Setting terminal for the model
Front panel key input terminal
Ground terminal
Front panel key input terminal
Reference voltage (+3.3V) input terminal
Power supply terminal (+3.3V)
Not used
SCD-XA5400ES
MAIN BOARD IC1101 CXD9927R (RF AMP, SERVO DSP, HDMI TRANSMITTER)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19, 20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56 to 64
65
66
67 to 75
Pin Name
OSC
RFGC
IREF
AVDD3
AGND
DVDA
DVDB
DVDC
DVDD
DVDRF IP
MA
MB
MC
MD
SA
SB
TNI
TPI
MDI1, MDI2
LDO2
LDO1
SVDD3
CSO
RFLVL
SGND
V2REFO
V2O
VREFO
FEO
TEO
TEZISLV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
IOPMON
TRO
FOO
AGND18
AVDD18
USB_DP
USB_DM
USB_VDD3
USB_VSS
PAD_VRT
USB_VDD18
USB_VSS
DIR_ERROR
DIR_AUDIO
LIMITSW
MSW
DVDD18
HA2 to HA8, HA18,
HA19
DVDD3
XWR
HA16 to HA9, HA20
I/O
O
O
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
O
O
O
O
O
O
O
O
O
I
I
O
O
O
I
O
O
I/O
I/O
O
O
I
O
-
Description
RF offset cancellation capacitor connecting terminal
RF AGC loop capacitor connecting Not used
Reference current input terminal
Power supply terminal (+3.3V)
Ground terminal
AC coupled input path A
AC coupled input path B
AC coupled input path C
AC coupled input path D
AC coupled super audio CD RF signal input from the optical pick-up block
DC coupled main-beam RF signal input A
DC coupled main-beam RF signal input B
DC coupled main-beam RF signal input C
DC coupled main-beam RF signal input D
DC coupled sub-beam RF signal input A Not used
DC coupled sub-beam RF signal input B Not used
3 beam satellite PD signal negative input from the optical pick-up block
3 beam satellite PD signal positive input from the optical pick-up block
Laser power monitor input from the optical pick-up block
Laser diode drive signal output to the optical pick-up block (for super audio CD)
Laser diode drive signal output to the optical pick-up block (for CD)
Power supply terminal (+3.3V)
Central servo signal output terminal Not used
RFRP low pass output terminal Not used
Ground terminal
Reference voltage (+2.8V) output terminal
Reference voltage (+2V) output to the optical pick-up block
Reference voltage (+1.4V) output terminal
Focus error monitor output terminal Not used
Tracking error monitor output terminal Not used
O Slice level of tracking error signal output terminal Not used
Output to the internal operational amplifier Not used
Negative input from the internal operational amplifier Not used
Positive input from the motor driver
Spindle motor control signal output to the motor driver
Sled motor control signal output to the motor driver
Loading motor control signal output terminal
Power monitor terminal
Tracking coil control signal output to the coil driver
Focus coil control signal output to the coil driver
Ground terminal
Power supply terminal (+1.8V)
Two-way data (positive) bus terminal Not used
Two-way data (negative) bus terminal Not used
Power supply terminal (+3.3V)
Ground terminal
Not used
Power supply terminal (+1.8V)
Ground terminal
PLL lock error signal and data error flag output termnal Not used
PCM audio data output termnal Not used
Limit detection switch input terminal
CD/super audio CD selection signal output terminal "L": CD, "H": super audio CD
Power supply terminal (+1.8V)
O
Address signal output to the flash ROM
O
O
Power supply terminal (+3.3V)
Write enable signal output to the flash ROM
Address signal output to the flash ROM
43
SCD-XA5400ES
Pin No.
76
77
78
79, 80
81
82 to 86
87
88
89
90
91, 92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113 to 117
118
119 to 129
130
131
132
133
134
135
136
137, 138
139 to 141
142
143, 144
145
146
147
148
149 to 155
156
157
158
159
160
161
162
163
164
44
Pin Name
XROMCS
HA1
XRD
HD0, HD1
DVSS
HD2 to HD6
HA21
RESERVED
HD7
DVSS
HA17, HA0
DVDD18
FWD
REV
DVDD3
IFSDO
IFCK
xIFCS
IFSDI
SCL
SDA
CKSW
OCSW
RXD
TXD
ICE
xSYSRST
RESERVED
xIFBSY
DQM0
EEWP
RD7 to RD3
DVDD3
RD2 to RD0,
RD15 to RD8
TSD_M
DVDD3
DQM1
_RWE
_CAS
_RAS
_RCS
BA0, BA1
RA10, RA0, RA1
DVDD18
RA2, RA3
DVDD3
DRCLK
CKE
DVSS
RA11, RA9 to RA4
DVDD3
MUTE123
MUTE
DDC_DA
DVDD18
DDC_CLK
HTPLG
AGND3
EXT_RES
I/O
O
O
O
I/O
I/O
O
I/O
O
O
O
O
O
O
I
I
I/O
I
I
I
O
I
I
I
O
O
I/O
-
Description
Chip select signal output to the flash ROM
Address signal output to the flash ROM
Read enable signal output to the flash ROM
Two-way data bus terminal with the flash ROM
Ground terminal
Two-way data bus terminal with the flash ROM
Address signal output to the flash ROM
Not used
Two-way data bus terminal with the flash ROM
Ground terminal
Address signal output to the flash ROM
Power supply terminal (+1.8V)
Loading motor drive signal output terminal Not used
Loading motor drive signal output terminal Not used
Power supply terminal (+3.3V)
Serial data output to the system controller
Serial data transfer clock signal output to the system controller
Chip select signal output to the system controller
Serial data input from the system controller
Serial data transfer clock signal output to the EEPROM
Two-way data bus with the EEPROM
Chucking detection switch input terminal Not used
Disc table open/close detection switch input terminal Not used
Receive data input terminal Not used
Transmit data output terminal Not used
ICE mode enable signal input terminal Not used
Reset signal input from the system controller "L": reset
Not used
Busy signal input from the system controller
Data mask signal output to the SD-RAM
Write protect signal output to the EEPROM
Two-way data bus with the SD-RAM
Power supply terminal (+3.3V)
I/O
Two-way data bus with the SD-RAM
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I/O
I
-
Thermal shut down signal output to the motor/coil driver
Power supply terminal (+3.3V)
Data mask signal output to the SD-RAM
Write enable signal output to the SD-RAM
Column address strobe signal output to the SD-RAM
Row address strobe signal output to the SD-RAM
Chip select signal output to the SD-RAM
Bank address signal output to the SD-RAM
Address signal output to the SD-RAM
Power supply terminal (+1.8V)
Address signal output to the SD-RAM
Power supply terminal (+3.3V)
Serial data transfer clock signal output to the SD-RAM
Clock enable signal output to the SD-RAM
Ground terminal
Address signal output to the SD-RAM
Power supply terminal (+3.3V)
Muting signal output to the motor/coil driver
Muting signal output to the motor/coil driver
Serial data transfer clock signal output terminal
Power supply terminal (+1.8V)
Two-way data bus with terminal
HDMI hot-plug detection signal input terminal
Ground terminal
Not used
SCD-XA5400ES
Pin No.
165, 166
167
168, 169
170
171
172
173
174
175
176
177
178
179
180
181
182, 183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
Pin Name
AVDD3
EXT_CAP
AGND3, AGND18
TXCN
TXCP
AVDD18
TX0N
TX0P
AGND18
TX1N
TX1P
AVDD18
TX2N
TX2P
AGND18
R/Cr/Pr, B/Cb/Pb
DACVSSA
Y/G
DACVDDA
CVBS
DACVSSB
C
DACVDDB
Y
DACVSSC
FS
VREF
DACVDDC
VBUS_OE
VBUS_OC
SCORE/DIR_XSTATE
SPMCK
SPBCK
SPLRCK
ADIN(SPDATA)
ACLK
ABCK
ALRCK
MC_DATA(ADIN)
DVDD3
NO_USE
WIDE
REG_SEL/DSEL
TRG_SW
DVDD18
KMOD
XVOICE/DIR_CSFCAG
SPDIF
APLLVDD3
APLLCAP
APLLVSS, ADACVSS2,
218 to 220
ADACVSS1
221
DIR_CE
222
ASDATA3
223
ASDATA2
224
AVCM
225
ASDATA1
226
ASDATA0
227
DIR_CL
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
I
O
O
O
I
O
O
O
I
O
O
I
O
I
O
-
Description
Power supply terminal (+3.3V)
Not used
Ground terminal
TMDS clock signal (negative) output to the HDMI OUT connector
TMDS clock signal (positive) output to the HDMI OUT connector
Power supply terminal (+1.8V)
TMDS data (negative) output to the HDMI OUT connector
TMDS data (positive) output to the HDMI OUT connector
Ground terminal
TMDS data (negative) output to the HDMI OUT connector
TMDS data (positive) output to the HDMI OUT connector
Power supply terminal (+1.8V)
TMDS data (negative) output to the HDMI OUT connector
TMDS data (positive) output to the HDMI OUT connector
Ground terminal
Component video signal output terminal Not used
Ground terminal
Component video signal output terminal Not used
Power supply terminal (+3.3V)
Video signal output terminal Not used
Ground terminal
Chroma signal output terminal Not used
Power supply terminal (+3.3V)
Y signal output terminal Not used
Ground terminal
Full scale adjustment terminal
For reference voltage terminal
Power supply terminal (+3.3V)
VBUS control signal output terminal Not used
VBUS control signal input terminal
Source clock switching monitor input terminal Not used
Master clock signal output terminal Not used
Bit clock signal output terminal Not used
L/R sampling clock signal output terminal Not used
Audio serial data input terminal Not used
Master clock signal output terminal Not used
Bit clock signal output to the D/A converter
L/R sampling clock signal output to the D/A converter
Audio serial data input terminal Not used
Power supply terminal (+3.3V)
Not used
Normal/squeeze selection signal output terminal
Audio muting signal output to the system controller
Trigger detection switch input terminal Not used
Power supply terminal (+1.8V)
Karaoke mode status signal output terminal
Detection of MIC signal input terminal Not used
SPDIF digital audio signal output to the D/A converter
Power supply terminal (+3.3V)
Connection terminal for an external capacitor
-
Ground terminal
O
O
O
O
-
Not used
Audio serial data output to the D/A converter
Audio serial data output terminal Not used
Not used
Audio serial data output terminal Not used
Audio serial data output terminal
Not used
45
SCD-XA5400ES
Pin No.
228, 229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
248
249
250
251
252
253
254
255
256
46
Pin Name
ADACVDD1,
ADACVDD2
Rt/DIR_DI
Lt/DIR_DO
ADACVSS1
ADACVDD1
SADCVDD18
SADCVSS18
RFGND18
RFVDD18
XTALO
XTALI
JITFO
JITFN
PLLVSS
PLLVDD3
LPFON
LPFIP
LPFIN
LPFOP
ADCVDD3
ADCVSS
RFVDD3
RFRPDC
RFRPAC
HRFZC
CRTPLP
RFGND18
OSP
I/O
Description
-
Power supply terminal (+3.3V)
I
O
O
I
O
I
O
I
I
O
O
I
I
O
O
Serial data input terminal Not used
Serial data output terminal Not used
Ground terminal
Power supply terminal (+3.3V)
Power supply terminal (+1.8V)
Ground terminal
Ground terminal
Power supply terminal (+1.8V)
System clock output terminal Not used
System clock input terminal
Output terminal of the RF jitter meter
Input terminal of the RF jitter meter
Ground terminal
Power supply terminal (+3.3V)
Data PLL loop filter output terminal
Data PLL loop filter input terminal
Data PLL loop filter input terminal
Data PLL loop filter output terminal
Power supply terminal (+3.3V)
Ground terminal
Power supply terminal (+3.3V)
RF ripple detect output terminal
RF ripple detect input terminal
High frequency RF ripple zero crossing terminal
Defect level fi lter capacitor connecting terminal
Ground terminal
RF offset cancellation capacitor connecting terminal
SCD-XA5400ES
SECTION 7
EXPLODED VIEWS
Note:
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet’s Color
7-1.
• Abbreviation
CND : Canadian model
The components identified by mark 9 contain confidential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
Les composants identifiés par la marque
9 contiennent des informations confidentielles.
Suivre scrupuleusement les instructions
chaque fois qu’un composant est remplacé
et / ou réparé.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
CASE SECTION
5
6
7
not supplied
mechanism deck section
(CDM66F-DVBU101)
5
#1
3
not supplied
not supplied
#1
#1
DISPLAY board section
MAIN board section
3
3
1
#1
not supplied
4
2
Ref. No.
1
2
3
4
5
Part No.
Description
A-1544-225-A
3-087-053-01
4-860-518-00
3-704-515-11
2-580-630-01
PANEL ASSY, LOADING
+BVTP2.6 (3CR)
CUSHION
SCREW (BV/RING)
SCREW, +BVST 4X8
Remark
Ref. No.
6
7
#1
Part No.
Description
4-220-301-32
4-227-843-03
7-685-646-79
CASE
SCREW (TP), FLAT HEAD
SCREW +BVTP 3X8 TYPE2 IT-3
Remark
47
SCD-XA5400ES
7-2.
DISPLAY BOARD SECTION
not supplied
(KEY-L board)
56
59
58
56
not supplied
not supplied
57
supplied with
J801
not supplied
not supplied
55
56
56
not supplied
(HP board)
56
J801
not supplied
(LED board)
56
56
not
supplied
RV801
supplied with RV801
not supplied
56
not supplied
(KEY-R board)
54
not supplied
53
not supplied
(JOG board)
52
51
front panel section
Note: If wire (flat type) is replaced, install it after bending
it in the same form as that before replacement.
Ref. No.
Part No.
Description
51
52
53
54
55
X-4955-656-2
3-873-313-01
4-250-532-01
2-893-374-01
4-942-568-41
KNOB (SEL) ASSY
PLATE, INDICATION
KNOB (HP-VOL)
SPRING, RING
EMBLEM (NO.5), SONY
56
3-087-053-01
+BVTP2.6 (3CR)
48
Remark
Ref. No.
Part No.
Description
57
58
59
J801
4-220-711-01
A-1544-255-A
1-835-567-51
1-770-904-11
INDICATOR (FILTER)
DISPLAY BOARD, COMPLETE
WIRE (FLAT TYPE) (19 CORE)
JACK (LARGE TYPE) (PHONES)
RV801
1-227-185-11
RES, VAR, CARBON (PHONE LEVEL)
Remark
SCD-XA5400ES
7-3.
FRONT PANEL SECTION
not supplied
114
117
116
115
102
103
104
not
supplied
105
106
118
109
not
supplied
not
supplied
108
105
110
111
107
112
113
101
#1
Ref. No.
Part No.
Description
101
101
102
103
104
3-873-309-01
3-873-309-11
4-250-643-01
4-246-567-91
4-246-563-31
PANEL, FRONT (AEP)
PANEL, FRONT (US, CND)
SHEET (ES-A), ADHESIVE
BUTTON (PLAY) (I/1)
ESCUTCHEON (A)
105
106
107
108
109
3-325-697-21
4-220-317-01
4-975-105-01
4-246-563-21
4-246-568-01
WASHER
BUTTON (FILTER)
WINDOW, RAY CATCHER
ESCUTCHEON (A)
BUTTON (OPEN) (A)
Remark
Ref. No.
Part No.
Description
110
111
112
113
114
4-246-567-01
4-246-567-31
4-246-567-61
X-4950-462-1
3-873-310-01
BUTTON (PLAY) (N)
BUTTON (PLAY) (X)
BUTTON (PLAY) (x)
LENS ASSY, LED
BASE (L), PANEL
115
116
117
118
#1
3-873-312-01
4-235-619-01
3-087-053-01
3-873-311-01
7-685-646-79
BASE (C), PANEL
PACKING (LOADING)
+BVTP2.6 (3CR)
BASE (R), PANEL
SCREW +BVTP 3X8 TYPE2 IT-3
Remark
49
SCD-XA5400ES
7-4.
MAIN BOARD SECTION
#1
not supplied
154
155
152
154
PT003
not
supplied
#1
153
PT002
#1
#2
not supplied
not supplied
#1
#1
AUDIO board section
151
Ref. No.
Part No.
Description
151
151
152
153
154
A-1544-253-A
A-1560-484-A
3-703-249-02
3-655-653-01
1-828-326-51
POWER BOARD, COMPLETE (US, CND)
POWER BOARD, COMPLETE (AEP)
SCREW, S TIGHT, +PTTWH 3X6
BAND (TAITON), BINDING
WIRE (FLAT TYPE) (13 CORE)
9 155
A-1567-301-A
MAIN BOARD, COMPLETE (for SERVICE)
(US, CND)
50
Remark
Ref. No.
Part No.
Description
155
PT002
PT002
PT003
A-1567-313-A
1-445-487-11
1-445-488-11
1-445-483-11
MAIN BOARD, COMPLETE (for SERVICE) (AEP)
TRANSFORMER, POWER (US, CND)
TRANSFORMER, POWER (AEP)
TRANSFORMER, POWER (US, CND)
0 PT003
#1
#2
1-445-484-11
7-685-646-79
7-682-547-04
TRANSFORMER, POWER (AEP)
SCREW +BVTP 3X8 TYPE2 IT-3
SCREW +B 3X6
9
0
0
0
Remark
SCD-XA5400ES
7-5.
AUDIO BOARD SECTION
#1
not supplied
F001
F002
#1
203
202
202
#1
202
205
206
204
#1
201
202
#1
#3
not supplied
#1
206
chassis section
Ref. No.
Part No.
Description
201
201
202
203
203
A-1544-254-A
A-1544-320-A
4-237-065-01
A-1544-251-A
A-1560-483-A
STANDBY BOARD, COMPLETE (US, CND)
STANDBY BOARD, COMPLETE (AEP)
CLAMP (L35)
AUDIO BOARD, COMPLETE (US, CND)
AUDIO BOARD, COMPLETE (AEP)
Remark
0 204
205
1-821-082-41
2-580-644-01
AC INLET (2P) (- AC IN)
SCREW, +KTP2 3X8
Ref. No.
Part No.
Description
206
0 F001
0 F001
4-860-518-00
1-532-389-33
1-532-501-33
CUSHION
FUSE (T500mA/250V) (AEP)
FUSE (T800mA/250V) (US, CND)
0 F002
0 F002
#1
#3
1-532-389-33
1-532-501-33
7-685-646-79
7-621-770-67
FUSE (T500mA/250V) (AEP)
FUSE (T800mA/250V) (US, CND)
SCREW +BVTP 3X8 TYPE2 IT-3
SCREW +B 2.6X6
Remark
51
SCD-XA5400ES
7-6.
CHASSIS SECTION
#5
not supplied
#1
not supplied
#1
252
253
#1
#5
252
not supplied
#1
not
supplied
253
#1
#1
252
not supplied
not supplied
#1
not
supplied
#1
not
supplied
251
not
#4
supplied
not supplied
not supplied
#1
251
#1
#4
#1
not supplied
#1
#1
251
#4
#1
#1
#1
Ref. No.
251
252
253
#1
52
#1
#1
#1
Part No.
Description
X-4955-348-1
4-237-065-01
4-860-518-00
7-685-646-79
FOOT ASSY
CLAMP (L35)
CUSHION
SCREW +BVTP 3X8 TYPE2 IT-3
#1
251
#1
#4
Remark
Ref. No.
Part No.
Description
#4
7-685-885-09
SCREW +BVTT 4X16 (S)
#5
7-685-645-79
SCREW +BVTP 3X6 TYPE2 IT-3
Remark
SCD-XA5400ES
7-7.
MECHANISM DECK SECTION
(CDM66F-DVBU101)
not supplied
508
511
507
not supplied
(OUT-SW board)
506
#6
505
510
not supplied
504
503
501
512
502
507
M001
base unit section
not supplied
(MOTOR board)
not supplied
509
Ref. No.
Part No.
Description
501
502
503
504
505
3-452-881-01
4-232-682-01
4-232-712-01
4-232-710-01
4-232-713-01
TRAY (66F)
CUSHION (66)
CAM (66)
PULLEY (LD)
BELT (LD)
506
507
4-232-711-01
3-087-053-01
GEAR (LD)
+BVTP2.6 (3CR)
Remark
Ref. No.
Part No.
Description
508
509
510
3-452-884-01
4-227-899-31
4-860-518-00
HOLDER (YOKE)
SCREW (DIA. 12), FROATING
CUSHION
511
512
M001
#6
3-452-883-01
4-237-065-01
A-4604-363-A
7-621-775-10
YOKE
CLAMP (L35)
MOTOR (L) ASSY (LOADING)
SCREW +B 2.6X4
Remark
53
SCD-XA5400ES
7-8.
BASE UNIT SECTION
551
553
551
551
552
553
553
556
553
554
555
Note: If wire (flat type) is replaced, install it after bending
it in the same form as that before replacement.
Ref. No.
551
0 552
553
554
54
Part No.
Description
Remark
3-087-599-01
8-820-322-04
2-634-618-11
3-452-882-01
INSULATOR SCREW
OPTICAL PICK-UP BLOCK (KHM-313CAB/C2RP)
INSULATOR
HOLDER (66F)
Ref. No.
Part No.
Description
555
1-835-373-51
WIRE (FLAT TYPE) (24 CORE)
556
4-113-450-01
CUSHION (66F)
Remark
SCD-XA5400ES
SECTION 8
ELECTRICAL PARTS LIST
Note:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• CAPACITORS
uF: μF
• COILS
uH: μH
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Ref. No.
• SEMICONDUCTORS
In each case, u: μ, for example:
uA. . : μA. . , uPA. . , μPA. . ,
uPB. . : μPB. . , uPC. . , μPC. . ,
uPD. . : μPD. .
• Abbreviation
CND : Canadian model
AUDIO
The components identified by mark 9 contain confidential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
When indicating parts by reference number, please include the board name.
Les composants identifiés par la marque
9 contiennent des informations confidentielles.
Suivre scrupuleusement les instructions
chaque fois qu’un composant est remplacé
et / ou réparé.
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
Part No.
Description
A-1544-251-A
A-1560-483-A
AUDIO BOARD, COMPLETE (US, CND)
AUDIO BOARD, COMPLETE (AEP)
**********************
Remark
Ref. No.
Part No.
Description
C206
C207
C208
C209
1-127-956-21
1-127-956-21
1-100-388-21
1-100-390-21
FILM CHIP
FILM CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
39uF
180uF
5%
5%
20%
20%
16V
16V
16V
6.3V
Remark
C210
C211
C212
C213
C214
1-127-956-21
1-136-287-11
1-136-287-11
1-127-956-21
1-127-956-21
FILM CHIP
FILM
FILM
FILM CHIP
FILM CHIP
0.1uF
0.0047uF
0.0047uF
0.1uF
0.1uF
5%
5%
5%
5%
5%
16V
100V
100V
16V
16V
C215
C216
C217
C218
C219
1-136-293-11
1-136-480-11
1-136-480-11
1-127-956-21
1-127-956-21
FILM
FILM
FILM
FILM CHIP
FILM CHIP
0.0082uF
0.0015uF
0.0015uF
0.1uF
0.1uF
5%
5%
5%
5%
5%
100V
100V
100V
16V
16V
C220
C221
C222
C223
C224
1-114-959-91
1-127-956-21
1-137-350-11
1-136-480-11
1-137-350-11
ELECT
FILM CHIP
FILM
FILM
FILM
47uF
0.1uF
0.015uF
0.0015uF
0.015uF
20%
5%
5%
5%
5%
100V
16V
100V
100V
100V
C225
C226
C227
C228
C229
1-136-480-11
1-127-956-21
1-127-956-21
1-114-959-91
1-127-956-21
FILM
FILM CHIP
FILM CHIP
ELECT
FILM CHIP
0.0015uF
0.1uF
0.1uF
47uF
0.1uF
5%
5%
5%
20%
5%
100V
16V
16V
100V
16V
C230
C231
C232
C252
C254
1-114-959-91
1-127-956-21
1-163-133-00
1-100-756-91
1-130-471-00
ELECT
FILM CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
47uF
0.1uF
470PF
0.047uF
0.001uF
20%
5%
5%
5%
100V
16V
50V (AEP)
50V
50V
C255
C256
C261
C262
C263
1-100-388-21
1-127-956-21
1-136-287-11
1-136-287-11
1-127-956-21
ELECT CHIP
FILM CHIP
FILM
FILM
FILM CHIP
39uF
0.1uF
0.0047uF
0.0047uF
0.1uF
20%
5%
5%
5%
5%
16V
16V
100V
100V
16V
C264
C265
C266
C267
C270
1-127-956-21
1-136-293-11
1-136-480-11
1-136-480-11
1-114-959-91
FILM CHIP
FILM
FILM
FILM
ELECT
0.1uF
0.0082uF
0.0015uF
0.0015uF
47uF
5%
5%
5%
5%
20%
16V
100V
100V
100V
100V
C271
C272
1-127-956-21
1-137-350-11
FILM CHIP
FILM
0.1uF
0.015uF
5%
5%
16V
100V
< CAPACITOR >
C151
C152
C153
C154
C155
1-100-566-91
1-100-566-91
1-162-917-11
1-162-918-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
15PF
18PF
470PF
10%
10%
5%
5%
10%
25V
25V
50V
50V
50V
C156
C157
C158
C159
C160
1-100-390-21
1-100-566-91
1-100-566-91
1-100-388-21
1-162-962-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
180uF
0.1uF
0.1uF
39uF
470PF
20%
10%
10%
20%
10%
6.3V
25V
25V
16V
50V
C161
C162
C163
C164
C165
1-100-566-91
1-100-566-91
1-100-390-21
1-127-956-21
1-128-528-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
FILM CHIP
ELECT
0.1uF
0.1uF
180uF
0.1uF
470uF
10%
10%
20%
5%
20%
25V
25V
6.3V
16V
25V
C166
C167
C168
C169
C170
1-124-699-11
1-124-699-11
1-100-566-91
1-162-962-11
1-100-566-91
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
220uF
0.1uF
470PF
0.1uF
20%
20%
10%
10%
10%
25V
25V
25V
50V
25V
C171
C172
C173
C174
C175
1-100-566-91
1-100-566-91
1-100-566-91
1-100-566-91
1-162-971-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.001uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
50V
C176
C177
C179
C180
C181
1-162-971-11
1-162-971-11
1-100-566-91
1-100-566-91
1-124-779-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.001uF
0.001uF
0.1uF
0.1uF
10uF
10%
10%
10%
10%
20%
50V
50V
25V
25V
16V
C182
C183
C200
C201
C204
1-162-962-11
1-100-390-21
1-100-756-91
1-100-756-91
1-130-471-00
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
470PF
180uF
0.047uF
0.047uF
0.001uF
10%
20%
5%
50V
6.3V
50V
50V
50V
C205
1-100-388-21
ELECT CHIP
39uF
20%
16V
55
SCD-XA5400ES
AUDIO
Ref. No.
Part No.
Description
C273
C274
C275
1-136-480-11
1-137-350-11
1-136-480-11
FILM
FILM
FILM
0.0015uF
0.015uF
0.0015uF
5%
5%
5%
100V
100V
100V
Remark
C276
C277
C278
C279
C280
1-127-956-21
1-127-956-21
1-114-959-91
1-127-956-21
1-114-959-91
FILM CHIP
FILM CHIP
ELECT
FILM CHIP
ELECT
0.1uF
0.1uF
47uF
0.1uF
47uF
5%
5%
20%
5%
20%
16V
16V
100V
16V
100V
C281
C282
C291
C292
C293
1-127-956-21
1-163-133-00
1-127-956-21
1-127-956-21
1-100-756-91
FILM CHIP
CERAMIC CHIP
FILM CHIP
FILM CHIP
CERAMIC CHIP
0.1uF
470PF
0.1uF
0.1uF
0.047uF
5%
5%
5%
5%
16V
50V (AEP)
16V
16V
50V
C294
C295
C296
C297
1-112-080-11
1-112-080-11
1-112-099-11
1-112-099-11
ELECT
ELECT
ELECT
ELECT
470uF
470uF
4.7uF
4.7uF
20%
20%
20%
20%
10V
10V
50V
50V
Ref. No.
Part No.
Description
Remark
< JACK >
J201
J202
1-818-094-11
1-764-393-11
J251
J252
1-818-095-11
1-764-393-11
JACK, PIN 1P (AUDIO OUT UNBALANCED L)
CONNECTOR (XLR TYPE) 3P
(AUDIO OUT UNBALANCED L)
JACK, PIN 1P (AUDIO OUT UNBALANCED R)
CONNECTOR (XLR TYPE) 3P
(AUDIO OUT UNBALANCED R)
< JUMPER RESISTOR/FERRITE BEAD >
JW150
JW150
1-216-295-91
1-469-670-21
SHORT CHIP
0 (AEP)
FERRITE, EMI (SMD) (2012) (US, CND)
< TRANSISTOR >
< CONNECTOR >
Q151
Q201
Q202
Q203
Q204
8-729-027-43
8-729-027-23
8-729-027-23
8-729-027-43
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTA114EKA-T146
DTA114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
Q252
Q253
Q291
Q292
Q293
8-729-027-23
8-729-027-43
8-729-027-23
8-729-027-43
8-729-027-23
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114EKA-T146
DTC114EKA-T146
DTA114EKA-T146
DTC114EKA-T146
DTA114EKA-T146
CN151
CN152
* CN154
CN155
CN156
1-785-468-41
1-785-468-41
1-569-974-11
1-691-766-11
1-564-505-11
CONNECTOR, FFC/FPC 13P
CONNECTOR, FFC/FPC 13P
PIN, CONNECTOR (PC BOARD) 3P
PLUG (MICRO CONNECTOR) 4P
PLUG, CONNECTOR 2P
CN291
1-779-978-11
PIN, CONNECTOR 3P
< DIODE >
D201
D202
D252
D291
6-501-817-01
6-501-817-01
6-501-817-01
6-501-817-01
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
< TERMINAL >
EE151
EE152
EE153
1-780-318-11
1-780-318-11
1-780-318-11
TERMINAL
TERMINAL
TERMINAL
< FERRITE BEAD >
FB151
FB152
FB153
1-469-139-21
1-469-152-11
1-469-152-11
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
< IC >
IC151
IC152
IC153
IC154
IC154
6-708-071-01
8-759-242-70
6-702-302-01
6-703-227-01
8-759-828-44
IC
IC
IC
IC
IC
FS7140-01G
TC7WU04F
TK11133CSCL-G
TK11131CSCL-G (US, CND)
NJM2870F33 (TE2) (AEP)
IC155
IC156
IC201
IC202
IC203
8-759-083-94
6-700-067-01
8-759-828-44
6-707-503-01
8-759-566-39
IC
IC
IC
IC
IC
TC7W74FU
HD74LV161ATELL
NJM2870F33 (TE2)
DSD1796DBR
OPA2132UA/2K5
IC204
IC205
IC206
IC253
IC255
8-759-566-39
8-759-447-30
8-759-082-58
8-759-566-39
8-759-447-30
IC
IC
IC
IC
IC
OPA2132UA/2K5
NJM2114M-TE2
TC7W08FU
OPA2132UA/2K5
NJM2114M-TE2
IC291
IC292
8-759-700-09
8-759-592-44
IC NJM2043M-D
IC TC7SZ04FU (TE85R)
56
< RESISTOR >
R150
R151
R152
R153
R154
1-216-801-11
1-216-811-11
1-216-801-11
1-216-815-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
150
22
330
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R155
R156
R157
R158
R159
1-216-809-11
1-216-801-11
1-216-801-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
22
22
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R160
R161
R162
R163
R164
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
22
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R165
R166
R167
R168
R169
1-216-801-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R171
R173
R174
R175
R176
1-216-833-11
1-216-833-11
1-216-833-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R177
R178
R179
R180
R181
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
22
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R182
R183
R184
R185
R201
1-216-801-11
1-216-801-11
1-216-833-11
1-216-833-11
1-218-716-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
10K
10K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
SCD-XA5400ES
AUDIO
Ref. No.
Part No.
Description
Remark
Ref. No.
RY291
R202
R203
R204
R205
R206
1-247-750-11
1-247-750-11
1-247-749-11
1-247-750-11
1-247-749-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
680
560
680
560
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
R207
R208
R209
R210
R211
1-247-749-11
1-247-750-11
1-247-749-11
1-249-194-11
1-214-921-00
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
560
220
220K
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/3W
1/3W
R212
R213
R222
R223
R224
1-249-162-11
1-216-833-11
1-247-749-11
1-247-750-11
1-247-749-11
CARBON
METAL CHIP
CARBON
CARBON
CARBON
10
10K
560
680
560
5%
5%
5%
5%
5%
1/3W
1/10W
1/2W
1/2W
1/2W
R225
R226
R227
R228
R229
1-247-749-11
1-247-750-11
1-247-749-11
1-249-194-11
1-214-921-00
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
560
220
220K
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/3W
1/3W
R230
R231
R232
R233
R252
1-249-162-11
1-249-194-11
1-214-921-00
1-249-162-11
1-247-750-11
CARBON
CARBON
CARBON
CARBON
CARBON
10
220
220K
10
680
5%
5%
5%
5%
5%
1/3W
1/3W
1/3W
1/3W
1/2W
R253
R254
R255
R256
R257
1-247-750-11
1-247-749-11
1-247-750-11
1-247-749-11
1-247-749-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
560
680
560
560
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
R258
R259
R260
R261
R262
1-247-750-11
1-247-749-11
1-249-194-11
1-214-921-00
1-249-162-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
560
220
220K
10
5%
5%
5%
5%
5%
1/2W
1/2W
1/3W
1/3W
1/3W
R272
R273
R274
R275
R276
1-247-749-11
1-247-750-11
1-247-749-11
1-247-749-11
1-247-750-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
680
560
560
680
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
R277
R278
R279
R280
R281
1-247-749-11
1-249-194-11
1-214-921-00
1-249-162-11
1-249-194-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
220
220K
10
220
5%
5%
5%
5%
5%
1/2W
1/3W
1/3W
1/3W
1/3W
R282
R283
R288
R289
R291
1-214-921-00
1-249-162-11
1-216-809-11
1-216-809-11
1-216-841-11
CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
220K
10
100
100
47K
5%
5%
5%
5%
5%
1/3W
1/3W
1/10W
1/10W
1/10W
R292
R293
R294
R295
R299
1-216-841-11
1-216-809-11
1-216-853-11
1-216-853-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
470K
470K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Part No.
Description
1-755-485-11
RELAY
DISPLAY
HP
Remark
< VIBRATOR >
X151
1-767-286-11 VIBRATOR, CRYSTAL (22.5792MHz)
************************************************************
*
A-1544-255-A
DISPLAY BOARD, COMPLETE
***********************
4-945-292-01
4-949-935-41
HOLDER, INDICATION TUBE
CUSHION (FL)
< CAPACITOR >
C803
C804
C806
C807
C808
1-162-970-11
1-126-157-11
1-162-962-11
1-162-962-11
1-162-962-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
10uF
470PF
470PF
470PF
10%
20%
10%
10%
10%
25V
16V
50V
50V
50V
C810
C811
C812
C813
C818
1-162-949-11
1-126-157-11
1-100-566-91
1-100-566-91
1-115-339-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
10uF
0.1uF
0.1uF
0.1uF
5%
20%
10%
10%
10%
50V
16V
25V
25V
50V
< CONNECTOR >
CN803
* CN804
* CN805
1-779-556-21
1-568-946-11
1-568-942-11
CONNECTOR, FFC (LIF (NON-ZIF)) 19P
PIN, CONNECTOR 8P
PIN, CONNECTOR 4P
< DIODE >
D801
6-501-817-01
DIODE MA2J1110GLS0
< IC >
IC801
IC802
IC803
6-600-349-31
6-705-899-01
8-759-828-44
IC NJL24H400A
IC ML9208-03MBZ03B
IC NJM2870F33 (TE2)
< FLUORESCENT INDICATOR TUBE >
ND801
1-483-035-11
INDICATOR TUBE, FLUORESCENT
< TRANSISTOR >
Q802
8-729-027-43
TRANSISTOR
DTC114EKA-T146
< RESISTOR >
R804
R807
R808
R809
R810
1-216-805-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
100
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R811
1-216-827-11 METAL CHIP
3.3K
5%
1/10W
R812
1-216-845-11 METAL CHIP
100K
5%
1/10W
************************************************************
HP BOARD
*********
< CAPACITOR >
< RELAY >
RY201
RY202
RY252
1-755-485-11
1-755-485-11
1-755-485-11
RELAY
RELAY
RELAY
C801
C802
C819
1-162-971-11
1-162-971-11
1-100-566-91
CERAMIC CHIP 0.001uF
CERAMIC CHIP 0.001uF
CERAMIC CHIP 0.1uF
10%
10%
10%
50V
50V
25V
57
SCD-XA5400ES
HP
Ref. No.
JOG
KEY-L
Part No.
KEY-R
LED
MAIN
Description
Remark
Ref. No.
Part No.
Description
Remark
< CONNECTOR >
< RESISTOR >
CN801
1-779-978-11
PIN, CONNECTOR 3P
R813
R814
R815
R816
R817
< JACK >
J801
1-770-904-11
JACK (LARGE TYPE) (PHONES)
1-216-821-11
1-216-821-11
1-216-825-11
1-216-811-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
2.2K
150
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< FERRITE BEAD >
< SWITCH >
L801
L802
L803
1-410-397-21
1-410-397-21
1-410-397-21
FERRITE
FERRITE
FERRITE
1.1uH
1.1uH
1.1uH
S807
1-762-875-21 SWITCH, KEYBOARD (A)
S808
1-762-875-21 SWITCH, KEYBOARD (N)
S809
1-762-875-21 SWITCH, KEYBOARD (X)
S810
1-762-875-21 SWITCH, KEYBOARD (x)
************************************************************
< VARIABLE RESISTOR >
RV801
1-227-185-11 RES, VAR, CARBON (PHONE LEVEL)
************************************************************
LED BOARD (included in KEY-R board)
**********
JOG BOARD
**********
< CAPACITOR >
< CAPACITOR >
C816
C817
1-162-970-11
1-162-970-11
C814
C815
CERAMIC CHIP 0.01uF
CERAMIC CHIP 0.01uF
10%
10%
25V
25V
< CONNECTOR >
* CN808
S806
1-568-942-11
1-100-566-91
1-100-566-91
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
10%
10%
25V
25V
< LED >
PIN, CONNECTOR 4P
D802
8-719-046-41 LED SEL5521C-TP15 (N)
D803
8-719-046-39 LED SEL5821A-TP15 (X)
************************************************************
< ROTARY ENCODER >
9
A-1567-301-A
9
A-1567-313-A
1-478-268-11
ENCODER, ROTARY
(. ANS >, PUSH ENTER)
************************************************************
MAIN BOARD, COMPLETE (for SERVICE)
(US, CND)
MAIN BOARD, COMPLETE (for SERVICE) (AEP)
*********************
< CAPACITOR >
KEY-L BOARD
***********
< CAPACITOR >
C805
1-100-566-91
CERAMIC CHIP 0.1uF
10%
25V
< TRANSISTOR >
Q801
8-729-027-43
TRANSISTOR
DTC114EKA-T146
< RESISTOR >
R801
R802
R803
R805
R806
1-216-821-11
1-216-825-11
1-216-825-11
1-216-829-11
1-216-811-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
2.2K
2.2K
4.7K
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S801
1-762-875-21 SWITCH, KEYBOARD (l/1)
S802
1-570-969-11 SWITCH, KEY BOARD (TIME/TEXT)
S803
1-570-969-11 SWITCH, KEY BOARD (MULTI/2CH)
S804
1-570-969-11 SWITCH, KEY BOARD (SA-CD/CD)
S805
1-570-101-51 SWITCH, KEY BOARD (HDMI)
************************************************************
KEY-R BOARD (including LED board)
***********
< TRANSISTOR >
Q803
Q804
58
8-729-027-43
8-729-027-43
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTC114EKA-T146
C501
C502
C503
C507
C508
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C510
C515
C517
C518
C520
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-127-715-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.22uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C521
C522
C523
C526
C527
1-162-970-11
1-127-715-11
1-107-826-11
1-104-658-91
1-104-656-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.01uF
0.22uF
0.1uF
100uF
2200uF
10%
10%
10%
20%
20%
25V
16V
16V
10V
6.3V
C528
C531
C533
C538
C577
1-126-916-11
1-107-826-11
1-107-826-11
1-162-964-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1000uF
0.1uF
0.1uF
0.001uF
0.01uF
20%
10%
10%
10%
10%
6.3V
16V
16V
50V
25V
C578
C579
C580
C581
C582
1-162-970-11
1-126-933-11
1-126-933-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
100uF
100uF
0.01uF
0.1uF
10%
20%
20%
10%
10%
25V
16V
16V
25V
16V
C583
C584
C591
C592
1-104-658-91
1-104-658-91
1-162-970-11
1-162-970-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
100uF
0.01uF
0.01uF
20%
20%
10%
10%
10V
10V
25V
25V
SCD-XA5400ES
MAIN
Ref. No.
Part No.
Description
C593
1-104-658-91
ELECT
100uF
20%
10V
Remark
C594
C691
1-104-658-91
1-128-994-21
ELECT
ELECT CHIP
100uF
47uF
20%
20%
C692
1-107-826-11
CERAMIC CHIP 0.1uF
10%
C693
1-126-601-11
ELECT CHIP
20%
C1101
1-162-970-11
CERAMIC CHIP 0.01uF
10%
10V
10V
(US, CND)
16V
(US, CND)
50V
(US, CND)
25V
Part No.
Description
C1169
C1170
C1171
C1172
1-107-826-11
1-162-965-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.0015uF
0.1uF
0.1uF
10%
10%
10%
10%
16V
50V
16V
16V
C1174
C1175
C1176
C1177
C1179
1-162-970-11
1-162-970-11
1-162-970-11
1-126-925-91
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
470uF
0.1uF
10%
10%
10%
20%
10%
25V
25V
25V
10V
16V
C1103
C1105
C1106
C1108
C1109
1-107-826-11
1-128-994-21
1-162-970-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.01uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
16V
10V
25V
16V
16V
C1180
C1181
C1182
C1183
C1184
1-107-826-11
1-107-826-11
1-127-715-11
1-128-934-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.22uF
0.33uF
0.01uF
10%
10%
10%
20%
10%
16V
16V
16V
10V
25V
C1110
C1111
C1112
C1113
C1114
1-165-908-11
1-100-390-21
1-128-994-21
1-162-970-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
180uF
47uF
0.01uF
0.1uF
10%
20%
20%
10%
10%
10V
6.3V
10V
25V
16V
C1186
C1187
C1190
C1191
C1192
1-127-715-11
1-100-390-21
1-100-390-21
1-107-826-11
1-162-970-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
180uF
180uF
0.1uF
0.01uF
10%
20%
20%
10%
10%
16V
6.3V
6.3V
16V
25V
C1115
C1116
C1117
C1118
C1119
1-107-826-11
1-107-826-11
1-128-994-21
1-128-994-21
1-128-994-21
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
47uF
47uF
47uF
10%
10%
20%
20%
20%
16V
16V
10V
10V
10V
C1193
C1195
C1197
C1198
C1199
1-127-715-11
1-127-715-11
1-107-826-11
1-165-908-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.22uF
0.1uF
1uF
0.0047uF
10%
10%
10%
10%
10%
16V
16V
16V
10V
50V
C1120
C1121
C1122
C1123
C1124
1-165-908-11
1-165-908-11
1-165-908-11
1-165-908-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
1uF
10%
10%
10%
10%
10%
10V
10V
10V
10V
10V
C1203
C1205
C1206
C1208
C1209
1-162-970-11
1-164-230-11
1-164-230-11
1-162-970-11
1-164-677-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
220PF
220PF
0.01uF
0.033uF
10%
5%
5%
10%
10%
25V
50V
50V
25V
16V
C1125
C1126
C1127
C1129
C1130
1-107-826-11
1-107-826-11
1-162-970-11
1-165-989-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
10uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
25V
6.3V
16V
C1210
C1211
C1212
C1213
C1214
1-162-970-11
1-164-677-11
1-162-970-11
1-162-970-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.033uF
0.01uF
0.01uF
0.001uF
10%
10%
10%
10%
10%
25V
16V
25V
25V
50V
C1132
C1133
C1135
C1136
C1137
1-107-826-11
1-107-826-11
1-164-677-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.033uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
25V
16V
C1215
C1217
C1218
C1219
C1220
1-162-970-11
1-126-204-11
1-124-779-00
1-162-970-11
1-124-779-00
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
0.01uF
47uF
10uF
0.01uF
10uF
10%
20%
20%
10%
20%
25V
16V
16V
25V
16V
C1138
C1139
C1140
C1144
C1145
1-162-964-11
1-162-919-11
1-107-826-11
1-162-970-11
1-124-779-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.001uF
22PF
0.1uF
0.01uF
10uF
10%
5%
10%
10%
20%
50V
50V
16V
25V
16V
C1221
C1222
C1223
C1224
C1225
1-107-826-11
1-107-826-11
1-107-826-11
1-162-970-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.01uF
0.001uF
10%
10%
10%
10%
10%
16V
16V
16V
25V
50V
C1146
C1147
C1148
C1149
C1151
1-107-826-11
1-165-176-11
1-165-176-11
1-107-826-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.047uF
0.047uF
0.1uF
0.001uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
50V
C1226
C1233
C1701
C1702
C1703
1-162-964-11
1-162-968-11
1-162-923-11
1-165-908-11
1-127-956-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM CHIP
0.001uF
0.0047uF
47PF
1uF
0.1uF
10%
10%
5%
10%
5%
50V
50V
50V
10V
16V
C1154
C1155
C1156
C1158
C1159
1-107-826-11
1-162-970-11
1-162-970-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
16V
25V
25V
25V
16V
C1704
C1705
C1706
C1725
C1727
1-127-956-21
1-127-956-21
1-100-390-21
1-162-970-11
1-162-970-11
FILM CHIP
FILM CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
180uF
0.01uF
0.01uF
5%
5%
20%
10%
10%
16V
16V
6.3V
25V
25V
C1160
C1161
C1162
C1163
C1164
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C1728
C1729
C1730
C1801
C1802
1-128-994-21
1-127-715-11
1-127-715-11
1-162-923-11
1-162-923-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.22uF
0.22uF
47PF
47PF
20%
10%
10%
5%
5%
10V
16V
16V
50V
50V
C1165
1-107-826-11
CERAMIC CHIP 0.1uF
10%
16V
C2100
1-162-970-11
CERAMIC CHIP 0.01uF
10%
25V
2.2uF
Ref. No.
Remark
59
SCD-XA5400ES
MAIN
Ref. No.
Part No.
Description
C2108
C2109
C2110
C2114
1-127-760-11
1-126-916-11
1-126-916-11
1-107-826-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
4.7uF
1000uF
1000uF
0.1uF
10%
20%
20%
10%
6.3V
6.3V
6.3V
16V
Remark
C2115
C2116
C2117
C2118
C2119
1-165-989-11
1-107-826-11
1-165-989-11
1-107-826-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
10uF
0.1uF
0.001uF
10%
10%
10%
10%
10%
6.3V
16V
6.3V
16V
50V
C2130
C2502
C2503
C9972
1-162-970-11
1-164-172-11
1-127-760-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.0056uF
4.7uF
0.1uF
10%
10%
10%
10%
25V
25V
6.3V
16V
Ref. No.
1-785-468-41
1-820-117-41
1-817-199-51
1-691-772-11
1-815-763-32
CONNECTOR, FFC/FPC 13P
CONNECTOR, FFC/FPC 19P
CONNECTOR, FFC/FPC 9P
PLUG (MICRO CONNECTOR) 10P
CONNECTOR, FFC/FPC 24P
* CN1105
CN1110
CN1201
CN1202
CN1701
1-564-708-11
1-785-468-41
1-779-977-11
1-784-922-11
1-820-735-31
PIN, CONNECTOR (SMALL TYPE) 6P
CONNECTOR, FFC/FPC 13P
PIN, CONNECTOR 6P
PIN, CONNECTOR 5P
HDMI CONNECTOR (HDMI OUT)
CN1801
1-779-978-11
PIN, CONNECTOR 3P
Description
Remark
< IC >
< CONNECTOR >
CN501
CN502
CN504
* CN506
CN1101
Part No.
IC501
IC503
IC504
IC505
IC506
A-1567-243-A
6-708-922-01
6-712-613-01
6-712-613-01
6-712-613-01
IC
IC
IC
IC
IC
R5F3640DDFAR (for SERVICE)
PST3635NR
SI-3010KM-TLS
SI-3010KM-TLS
SI-3010KM-TLS
IC692
IC693
IC1101
IC1102
IC1103
8-759-675-54
6-600-349-21
6-711-953-01
6-808-155-01
(Not supplied)
IC
IC
IC
IC
IC
TC7W53FK (TE85R) (US, CND)
NJL23H400A (US, CND)
CXD9927R
S29AL032D70TF-SCD-0801
S-24CS64A01-J8T1G
IC1104
IC1105
IC1107
IC1110
IC1201
6-707-897-01
6-702-302-01
6-702-302-01
6-707-739-01
6-704-524-01
IC
IC
IC
IC
IC
EDS6416AHTA-75-E
TK11133CSCL-G
TK11133CSCL-G
MM1661JTRE
FAN8036L
IC1701
IC1702
IC1703
IC1705
IC1707
6-600-461-11
8-759-058-62
8-759-058-62
8-759-592-47
6-705-337-01
IC
IC
IC
IC
IC
TOTX147L (R) (DIGITAL OUT(CD) OPTICAL)
TC7S08FU (TE85R)
TC7S08FU (TE85R)
TC7SZ08FU (TE85R)
TK11150CSCL-G
IC1901
6-700-596-01
IC TC74LVX4053FT (EL)
< JACK >
J691
J1701
< DIODE >
D501
D502
D505
D691
D692
6-501-817-01
6-500-334-01
6-500-334-01
6-501-817-01
8-719-075-86
DIODE
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0
MC2836-T112-1
MC2836-T112-1
MA2J1110GLS0 (US, CND)
SID307BRTP19 (US, CND)
D693
D1801
D1802
D9712
6-501-817-01
6-501-817-01
6-501-817-01
6-501-817-01
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0 (US, CND)
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
1-563-330-31
1-818-300-11
JACK (IR REMOTE IN) (US, CND)
JACK, PIN 1P (DIGITAL OUT(CD) COAXIAL)
< COIL >
*
*
*
*
L1701
L1702
L1703
L1704
L1705
1-813-308-11
1-813-308-11
1-813-308-11
1-813-308-11
1-416-701-11
COMMON MODE CHOKE
COMMON MODE CHOKE
COMMON MODE CHOKE
COMMON MODE CHOKE
COIL (WITH CORE)
L1801
1-410-997-42
INDUCTOR
2.2uH
< TRANSISTOR >
< GROUND TERMINAL >
EB501
EB502
EB503
1-537-770-21
1-537-770-21
1-780-318-11
TERMINAL BOARD, GROUND
TERMINAL BOARD, GROUND
TERMINAL
Q503
Q1101
Q1102
Q1103
Q1105
8-729-620-07
6-550-008-01
6-550-653-01
8-729-027-52
8-729-028-27
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET
2SC3052EF-T1-LEF
UM6K1N-TN
QST8TR
DTC124EKA-T146
2SK2009 (TE85L)
Q1701
Q9724
Q9726
Q9728
Q9729
6-550-008-01
6-551-699-01
8-729-620-13
8-729-620-13
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UM6K1N-TN
ISA1602AM1TP-1EF
2SC4154TP-1EF
2SC4154TP-1EF
DTC114EKA-T146
< FERRITE BEAD >
FB505
FB508
FB510
FB1106
FB1107
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FB1108
FB1109
FB1111
FB1112
FB1113
1-469-324-21
1-469-324-21
1-469-670-21
1-469-670-21
1-469-670-21
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FB1115
FB1116
FB1117
FB1118
FB2101
1-469-670-21
1-469-670-21
1-469-670-21
1-469-670-21
1-469-324-21
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
FB2103
1-469-324-21
FERRITE, EMI (SMD) (2012)
< RESISTOR >
R501
R504
R506
R508
R509
1-216-857-11
1-216-833-11
1-216-833-11
1-216-864-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
1M
10K
10K
0 (AEP)
100
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R510
R511
R512
R513
R514
1-216-833-11
1-216-821-11
1-216-833-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
10K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Note: IC1103 cannot exchange with single. When this part
is damaged, exchange the entire mounted board.
60
SCD-XA5400ES
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R515
R516
R517
R518
R519
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
Ref. No.
R596
R597
R598
R599
R601
1-218-871-11
1-218-879-11
1-218-851-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
1.5K
1K
100
0.5%
0.5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R520
R521
R522
R523
R524
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R602
R603
R604
R650
R691
1-216-809-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-833-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100
0
0
100
10K
5%
1/10W
5%
5%
1/10W
1/10W
(US, CND)
R525
R526
R527
R528
R529
1-216-833-11
1-216-809-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
10K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R692
1-216-797-11
METAL CHIP
10
5%
R693
1-216-845-11
METAL CHIP
100K
5%
R694
1-216-833-11
METAL CHIP
10K
5%
R530
R531
R532
R533
R534
1-216-809-11
1-216-833-11
1-216-821-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
1K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R695
1-216-845-11
METAL CHIP
100K
5%
R696
1-216-809-11
METAL CHIP
100
5%
1/10W
(US, CND)
1/10W
(US, CND)
1/10W
(US, CND)
1/10W
(US, CND)
1/10W
(US, CND)
R535
R536
R538
R539
R540
1-216-809-11
1-216-864-11
1-216-857-11
1-216-833-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
1M
10K
10K
5%
1/10W
R697
1-216-809-11
METAL CHIP
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
R1101
R1102
R1103
R1105
1-216-809-11
1-216-864-11
1-218-864-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100
0
5.1K
10K
5%
1/10W
(US, CND)
1/10W
0.5%
5%
1/10W
1/10W
R542
R543
R544
R545
R546
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1106
R1107
R1108
R1109
R1110
1-216-833-11
1-216-833-11
1-216-857-11
1-216-864-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
10K
1M
0
47K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R551
R556
R557
R558
R559
1-216-809-11
1-216-841-11
1-216-841-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
47K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1111
R1112
R1113
R1114
R1115
1-216-809-11
1-211-977-11
1-211-977-11
1-216-845-11
1-211-977-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
22
22
100K
22
5%
0.5%
0.5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R560
R561
R562
R563
R564
1-216-841-11
1-216-845-11
1-216-841-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100K
47K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1116
R1117
R1118
R1120
R1121
1-216-821-11
1-216-841-11
1-216-801-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
22
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R565
R566
R567
R568
R569
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1123
R1124
R1125
R1126
R1128
1-216-864-11
1-216-841-11
1-216-805-11
1-216-805-11
1-216-805-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
47K
47
47
47
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R570
R574
R579
R580
R581
1-216-841-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
0
100
100
100
5%
1/10W
1-216-845-11
1-216-864-11
1-216-821-11
1-216-835-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
0
1K
15K
10K
1/10W
1/10W
1/10W
1/10W
R1132
R1133
R1135
R1136
R1137
5%
5%
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
R582
R583
R584
R585
R586
1-216-833-11
1-218-871-11
1-218-873-11
1-218-891-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
12K
68K
1K
5%
0.5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1138
R1139
R1140
R1141
R1142
1-216-833-11
1-216-864-11
1-216-821-11
1-216-855-11
1-216-809-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
1K
680K
100
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R587
R588
R589
R590
R592
1-218-871-11
1-218-883-11
1-218-867-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
10K
33K
6.8K
1K
0
0.5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
R1143
R1145
R1146
R1147
R1148
1-216-805-11
1-216-864-11
1-216-805-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
47
0
47
0
0
5%
1/10W
5%
1/10W
61
SCD-XA5400ES
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R1151
R1152
R1153
R1154
R1155
1-216-833-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
10K
0
0
0
0
5%
R1753
R1754
R1757
R1781
R1782
1-216-864-11
1-216-864-11
1-216-864-11
1-216-827-11
1-216-827-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
3.3K
3.3K
5%
5%
1/10W
1/10W
R1156
R1159
R1160
R1161
R1175
1-216-809-11
1-216-833-11
1-216-805-11
1-216-805-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
100
10K
47
47
0
5%
5%
5%
5%
R1783
R1784
R1785
R1786
R1801
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-211-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
75
0.5%
1/10W
R1185
R1186
R1191
R1193
R1198
1-216-805-11
1-216-833-11
1-216-821-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
10K
1K
1K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R2101
R2110
R2114
R2115
R2119
1-218-841-11
1-216-826-11
1-216-801-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
560
2.7K
22
0
0
0.5%
5%
5%
1/10W
1/10W
1/10W
R1204
R1205
R1206
R1207
R1208
1-216-822-11
1-216-833-11
1-216-833-11
1-216-826-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
10K
10K
2.7K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R2129
R2133
R2134
R2150
R2151
1-216-845-11
1-216-864-11
1-216-864-11
1-216-827-11
1-216-827-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
0
0
3.3K
3.3K
5%
1/10W
5%
5%
1/10W
1/10W
R1209
R1210
R1212
R1213
R1214
1-216-839-11
1-216-841-11
1-216-833-11
1-218-867-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
47K
10K
6.8K
15K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R2152
R2155
R2156
R2157
R2158
1-216-827-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1215
R1216
R1219
R1220
R1221
1-216-834-11
1-216-834-11
1-216-838-11
1-216-821-11
1-218-889-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
12K
27K
1K
56K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R2159
R2160
R2176
R2177
R2178
1-216-833-11
1-216-833-11
1-216-864-11
1-216-864-11
1-216-821-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
10K
10K
0
0
1K
5%
5%
1/10W
1/10W
5%
1/10W
R1223
R1224
R1225
R1226
R1229
1-218-895-11
1-216-833-11
1-218-895-11
1-218-889-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
100K
56K
12K
0.5%
5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R2180
R2184
R2185
R2187
R2200
1-216-833-11
1-216-809-11
1-216-809-11
1-216-805-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
47
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1230
R1231
R1232
R1233
R1234
1-218-893-11
1-218-875-11
1-218-877-11
1-218-883-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
82K
15K
18K
33K
10K
0.5%
0.5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R9918
R9920
R9922
R9924
R9928
1-216-821-11
1-216-864-11
1-216-833-11
1-216-821-11
1-216-837-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
10K
1K
22K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R1236
R1237
R1238
R1239
R1243
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R9929
R9934
R9935
R9941
R9945
1-216-837-11
1-216-833-11
1-216-864-11
1-216-838-11
1-216-813-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
22K
10K
0
27K
220
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R1246
R1247
R1254
R1701
R1702
1-216-829-11
1-216-821-11
1-216-833-11
1-218-285-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
10K
75
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1730
R1742
R1744
R1746
R1747
1-216-826-11
1-216-841-11
1-216-829-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
2.7K
47K
4.7K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R1748
R1749
R1750
R1751
R1752
1-216-864-11
1-216-824-11
1-216-824-11
1-216-864-11
1-216-864-11
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
0
1.8K
1.8K
0
0
5%
5%
1/10W
1/10W
62
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
Ref. No.
Remark
< COMPOSITION CIRCUIT BLOCK >
RB1103
RB1104
RB1105
RB1106
RB1107
1-234-400-21
1-234-400-21
1-234-944-21
1-234-944-21
1-234-400-21
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
RES, NETWORK 47 (1005X4)
RES, NETWORK 47 (1005X4)
CONDUCTOR, NETWORK (1005X4)
RB1108
RB1109
RB1110
RB1111
RB1112
1-234-400-21
1-234-400-21
1-234-400-21
1-234-400-21
1-234-400-21
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
RB1113
RB1114
RB1115
1-234-400-21
1-234-400-21
1-234-400-21
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
CONDUCTOR, NETWORK (1005X4)
SCD-XA5400ES
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
MOTOR
OUT-SW
Description
POWER
Remark
< DIODE >
< SWITCH >
S501
S502
1-692-991-11
1-692-991-11
SWITCH, SLIDE (DIGITAL OUT(CD))
SWITCH, SLIDE (HDMI PRIORITY)
< VIBRATOR >
X501
1-795-121-21 VIBRATOR, CERAMIC (5MHz)
************************************************************
MOTOR BOARD
*************
< CONNECTOR >
CN010
CN011
1-564-721-11
1-506-481-11
PIN, CONNECTOR (SMALL TYPE) 5P
PIN, CONNECTOR 2P
D101
D102
D103
D104
D105
8-719-210-33
8-719-210-33
8-719-210-33
8-719-210-33
8-719-210-39
DIODE
DIODE
DIODE
DIODE
DIODE
EC10DS2
EC10DS2
EC10DS2
EC10DS2
EC10QS-04
D106
D107
D108
D109
D110
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
DIODE
DIODE
DIODE
DIODE
DIODE
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
D111
D112
D113
D114
D115
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
DIODE
DIODE
DIODE
DIODE
DIODE
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
D116
D117
D118
D119
D120
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
DIODE
DIODE
DIODE
DIODE
DIODE
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
D121
D122
D123
D124
D125
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
8-719-210-39
DIODE
DIODE
DIODE
DIODE
DIODE
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
EC10QS-04
D126
D127
D128
D129
D130
8-719-210-39
8-719-210-39
8-719-210-39
8-719-083-70
8-719-069-54
DIODE
DIODE
DIODE
DIODE
DIODE
EC10QS-04
EC10QS-04
EC10QS-04
UDZSNPTE-1727B
UDZSNPTE-175.1B
< SWITCH >
SW010 1-572-086-11 SWITCH, LEAF (CHUCKING)
************************************************************
OUT-SW BOARD
*************
< SWITCH >
SW011 1-762-424-11 SWITCH, MICRO (DISC IN/OUT)
************************************************************
A-1544-253-A
A-1560-484-A
POWER BOARD, COMPLETE (US, CND)
POWER BOARD, COMPLETE (AEP)
***********************
< CAPACITOR >
C101
C102
C103
C104
C105
1-128-576-11
1-126-767-11
1-112-425-11
1-107-887-31
1-107-887-31
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
1000uF
6800uF
10000uF
10000uF
20%
20%
20%
20%
20%
63V
16V
25V
16V
16V
C106
C107
C108
C109
C110
1-112-093-11
1-112-094-11
1-112-094-11
1-126-925-91
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
2200uF
2200uF
2200uF
470uF
10uF
20%
20%
20%
20%
20%
25V
35V
35V
10V
50V
C111
C112
C113
C114
C115
1-137-150-11
1-137-150-11
1-137-150-11
1-112-093-11
1-128-339-31
FILM
FILM
FILM
ELECT
ELECT
0.01uF
0.01uF
0.01uF
2200uF
2200uF
5%
5%
5%
20%
20%
100V
100V
100V
25V
16V
C116
C117
C118
C119
1-128-339-31
1-124-703-51
1-124-703-51
1-124-703-51
ELECT
ELECT
ELECT
ELECT
2200uF
2200uF
2200uF
2200uF
20%
20%
20%
20%
16V
25V
25V
25V
< IC >
IC101
IC102
IC103
IC104
IC105
8-759-390-48
8-759-473-41
6-708-659-01
8-759-390-48
8-759-450-47
IC
IC
IC
IC
IC
uPC2406AHF
BA10T
BA00BC0WT-V5
uPC2406AHF
BA05T
IC106
IC107
6-713-034-01
6-712-106-01
IC KIA7812API-U/PF
IC KIA7912PI
< TRANSISTOR >
< CONNECTOR >
CN101
CN102
CN103
* CN104
CN105
1-691-770-21
1-691-769-11
1-784-922-11
1-691-772-11
1-691-770-11
PLUG (MICRO CONNECTOR) 8P
PLUG (MICRO CONNECTOR) 7P
PIN, CONNECTOR 5P
PLUG (MICRO CONNECTOR) 10P
PLUG (MICRO CONNECTOR) 8P
CN106
1-784-921-11
PIN, CONNECTOR 4P
Q101
8-729-230-27
TRANSISTOR
2SA1213Y-TE12L
< RESISTOR >
R101
R102
R103
R104
R105
1-249-429-11
1-249-429-11
1-247-843-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
3.3K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R106
R107
R108
1-247-863-91
1-247-883-00
1-249-439-11
CARBON
CARBON
CARBON
22K
150K
68K
5%
5%
5%
1/4W
1/4W
1/4W
< THERMISTOR >
0 TH101
1-803-988-11 THERMISTOR, POSITIVE
0 TH102
1-803-988-11 THERMISTOR, POSITIVE
0 TH103
1-804-046-21 THERMISTOR, POSITIVE (RXE030) (AEP)
************************************************************
63
SCD-XA5400ES
STANDBY
Ref. No.
Part No.
Description
A-1544-254-A
A-1544-320-A
STANDBY BOARD, COMPLETE (US, CND)
STANDBY BOARD, COMPLETE (AEP)
************************
Remark
7-685-646-79
SCREW +BVTP 3X8 TYPE2 IT-3
Ref. No.
R57
0 R60
R61
Part No.
Description
1-249-439-11
1-249-389-91
1-249-415-11
CARBON
CARBON
CARBON
Remark
68K
4.7
680
5%
5%
5%
1/4W
1/4W
1/4W
F
< RELAY >
0 RY01
< CAPACITOR >
C51
0 C52
C53
C54
C55
1-126-964-11
1-112-887-51
1-126-943-11
1-164-315-11
1-136-287-11
ELECT
CERAMIC
ELECT
CERAMIC CHIP
FILM
10uF
0.01uF
2200uF
470PF
0.0047uF
20%
20%
20%
5%
5%
50V
250V
25V
50V
100V
C56
C57
C58
0 C59
C60
1-137-465-11
1-126-941-11
1-100-566-91
1-112-887-51
1-126-941-11
MYLAR
ELECT
CERAMIC CHIP
CERAMIC
ELECT
0.056uF
470uF
0.1uF
0.01uF
470uF
5%
20%
10%
20%
20%
100V
25V
25V
250V
25V
1-755-266-11
RELAY, AC POWER
< TRANSFORMER >
0 T002
0 T002
1-445-518-11
1-445-519-11
POWER SOURCE TRANSFORMER (US, CND)
POWER SOURCE TRANSFORMER (AEP)
< THERMISTOR >
0 TH50
1-804-046-21 THERMISTOR, POSITIVE (RXE030)
*************************************************************
MISCELLANEOUS
**************
< CONNECTOR >
CN001
CN002
CN003
* CN004
1-784-921-11
1-770-128-11
1-564-321-00
1-564-321-21
59
154
0 204
0 552
555
PIN, CONNECTOR 4P
PIN, CONNECTOR (3.96mm PITCH) 2P
PIN, CONNECTOR (3.96mm PITCH) 2P
PIN, CONNECTOR (3.96mm PITCH) 2P
< DIODE >
D52
D53
D54
D55
D56
8-719-210-21
8-719-210-21
8-719-210-21
8-719-210-21
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
D57
D58
8-719-991-33
8-719-991-33
DIODE 1SS133T-77
DIODE 1SS133T-77
0
0
0
0
11EQS04
11EQS04
11EQS04
11EQS04
1SS133T-77
F001
F001
F002
F002
M001
1-835-567-51
1-828-326-51
1-821-082-41
8-820-322-04
1-835-373-51
WIRE (FLAT TYPE) (19 CORE)
WIRE (FLAT TYPE) (13 CORE)
AC INLET (2P) (- AC IN)
OPTICAL PICK-UP BLOCK (KHM-313CAB/C2RP)
WIRE (FLAT TYPE) (24 CORE)
1-532-389-33
1-532-501-33
1-532-389-33
1-532-501-33
A-4604-363-A
FUSE (T500mA/250V) (AEP)
FUSE (T800mA/250V) (US, CND)
FUSE (T500mA/250V) (AEP)
FUSE (T800mA/250V) (US, CND)
MOTOR (L) ASSY (LOADING)
0 PT002
1-445-487-11 TRANSFORMER, POWER (US, CND)
0 PT002
1-445-488-11 TRANSFORMER, POWER (AEP)
0 PT003
1-445-483-11 TRANSFORMER, POWER (US, CND)
0 PT003
1-445-484-11 TRANSFORMER, POWER (AEP)
*************************************************************
< EARTH TERMINAL >
* EE51
1-537-738-21
ACCESSORIES
************
TERMINAL, EARTH
1-480-856-11
1-791-732-12
< FUSE HOLDER >
FH01
FH02
FH03
FH04
IC51
IC52
1-533-233-11
1-533-233-11
1-533-233-11
1-533-233-11
8-759-450-47
6-708-659-01
FUSE HOLDER
FUSE HOLDER
FUSE HOLDER
FUSE HOLDER
0
0
1-824-964-13
1-831-474-11
4-000-691-11
< IC >
4-000-691-21
IC BA05T
IC BA00BC0WT-V5
4-000-691-31
4-000-691-41
< COIL >
4-000-691-51
0 L51
1-421-915-11
COIL, LINE FILTER
4-000-691-61
REMOTE COMMANDER (RM-ASU042)
CORD, CONNECTION
(Audio connecting cord (Red and White plugs))
CORD, POWER (US, CND)
CORD, POWER (AEP)
MANUAL, INSTRUCTION (ENGLISH, FRENCH)
MANUAL, INSTRUCTION (SPANISH, GERMAN)
(AEP)
MANUAL, INSTRUCTION (DUTCH, ITALIAN)
(AEP)
MANUAL, INSTRUCTION (SPANISH, POLISH)
(AEP)
MANUAL, INSTRUCTION (DANISH, FINNISH)
(AEP)
MANUAL, INSTRUCTION (PORTUGUESE) (AEP)
< TRANSISTOR >
Q51
Q52
8-729-119-78
8-729-119-78
TRANSISTOR
TRANSISTOR
4-000-691-71
4-000-692-11
4-000-692-21
2SC2785-HFE
2SC2785-HFE
4-000-692-31
4-000-692-41
< RESISTOR >
R51
R52
R53
R54
R55
1-249-429-11
1-249-427-11
1-247-863-91
1-249-421-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
6.8K
22K
2.2K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R56
1-247-883-00
CARBON
150K
5%
1/4W
MANUAL, INSTRUCTION (RUSSIAN) (AEP)
MANUAL, INSTRUCTION (GREEK) (AEP)
MANUAL, INSTRUCTION (HUNGARIAN, CZECH)
(AEP)
MANUAL, INSTRUCTION (TURKISH) (AEP)
MANUAL, INSTRUCTION (SLOVAKIAN) (AEP)
Note: If wire (flat type) is replaced, install it after bending
it in the same form as that before replacement.
64
SCD-XA5400ES
MEMO
65
SCDXA5400ES
REVISION HISTORY
Checking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
Ver.
Date
1.0
2008.08
Description of Revision
New