Download Craftsman 360.796800 Owner`s manual

SEA/ S I
OWNER'S
MANUAL
MODEL NO.
360.796800
CRRFTSHRN°
CAUTION:
READ AND FOLLOW
ALL SAFETY RULES
AND INSTRUCTIONS
BEFORE OPERATING
EQUIPMENT
4.5 HP, 2 CYCLE
54cc/3.3
cu. in.
229 MPH/589
CFM
BACKPACK AIR BLOWER
•
•
•
•
•
Sears,
Assembly
Operation
Customer
Responsibilities
Service and Adjustments
Repair Parts
Roebuck
and
Co., Hoffman
Estates,
IL 60179
U.S.A.
WARNINGS
A
AND SAFETY
INSTRUCTIONS
CAUTION: ALWAYS DISCONNECT SPARK PLUG WIRE AND PLACE WHERE IT CAN- A
NOT
CONTACT SPARKADJUSTING
PLUG TO PREVENT
ACCIDENTAL
uP, TRANSPORTING,
OR MAKING
REPAIRS, STARTING WHEN sE'ITING _H_
TRAINING:
• Always be sure of yourfooting. Use.extracaution in
wet or slippery grass. Walk - Don't Run.
Read the operator's manual carefully• Become familiar
•
Do not put hands or feet near rotating parts. Keep
with the controls and know how to operate your air
clear of the nozzle opening at all times.
blower propedy.
• Always stop the engine whenever you leave or are
• Do not allow children to use your air blower. Never
not using your air blower.
allow adults to use air blower without proper instructions.
• Never direct discharge of matedal toward bystanders nor allow anyone near the air blower while you
• Keep the area of operationclear of all persons,
are operating it.
especially small children and pets.
• Use air blower only as the manufacturer intended
and as described in this manual.
• Do not operate air blower if it has been dropped or
damaged in any manner. Always have damage
repaired before using your air blower.
• Do not use accessory attachments that are not
recommended by the manufacturer. Use of such
attachments may be hazardous.
PREPARATION:
• Always wear safety glasses or eye shields when
starting and while using your air blower.
• Dress properly. Do not operate air blower when
barefoot or weadng open sandals. Wear only solid
shoes with good traction.
• Wear long-sleeved clothes that are snug fitting.
Avoid weadng loose clothing.
Wear either tightly cuffed or cuffless pants.
Wear heanng"protection even w_en working for a
short period of time. Rememberk_.hearingdamage is
cumulative.
• Wear protective, non-slipglovesfor safer operation.
• Before cleaning, inspecting, or repaidng your air
blower, stop the engine and make absolutely sure
all moving parts have stopped. Then disconnect the
wire and keep it away from the spark plug to
prevent accidental starting.
• Do not adjust carburetor. Overspeeding, engine
damage or personal injury may result.
• Do not operate your air blower if it vibrates abnormally. Excessive vibration is an indication of
damage; stop the engine, safely check for the
cause of vibration and repair as needed.
• Do not run the engine indoors. Exhaust fumes are
dangerous.
• Never operate your air blower without proper
guards,tubes or othersafety devices in ;)lace.
WA RN!NGCalifornia
Proposition
I
65
The engine exhaust from this product contains I
chemicals known to the State of California to cause I
cancer, birth defects or other reproductive harm. I
MAINTENANCE
AND STORAGE:
• Check the engine mountingbolts oftento be sure
they are tightenedpropedy.
• Check fuel tank before startingengine. Do not fillfuel
tank indoors,when the engine is runningor when the
engine is hot. Allow the engine to cool for several
minutesb0forefilling the fuel tank. Clear_off any
spilledgasolinebefore startingthe engine.
• Check all bolts,nuts and screwsat frequent intervals
for propertightnessto be sure air bloweris in safe
workingcondition.
• Always make edjustments beforestartingyourair
blower.Never attempt to do this while the engine is
running.
• To reducefire hazard, keep the engine free of debds
and excessive grease and oil.
• Use onlyin daylightor good artificiallight.
OPERATION
• Keep youreyes and mindo_ your air blower and the
area being blown. Don't letother interestsdistract
• Keep all safety devices in place and working.
• Allowengine to cool before stodng in any enclosure.
• Never store air blower with fuel in the tank insidea
buildingwhere fumes may reach an open flame or an
ignitionsourcesuch as hot water Ileater, space
heater, clothesdryer, etc.
yOU.
I_
IT MEANS- ATTENTION! I BECOME ALERTIII yOUR SAF_IS
INVOLVED.
:;i :iii, I
LOOK• FOR
THIS
SYMBOL,TO
POINT
OUT
IMPORTANT
SAFETY,
PRECAUTIONS.
' _,_'I
' " "
:
_: r _!:'_ _" _ _'_.:_ _ ,._
;'_.,'_*;_
i__'.: "_",'_" L:_:,_:_
CONGRATULATIONS on yourpurchase of a Sears
Backpack Air Blower. It has been designed, engineered
and manufacturedto give you the best possibledependabilityand performance.
Shouldyou experience any problemyou cannot easily
remedy, please contact yournearest Sears Service
Center Department. We have competentwell-trained
techniciansand the propertools to service or repair this
air blower.
Please read and retain this manual. The instructionswill
enable you to assemble and maintain your air blower
)ropedy.Always observe the "SAFETY RULES".
MODEL NO. 360.796800
PRODUCT SPECIFICATIONS
HORSEPOWER:
4.5
FUEL/OIL MIX CAPACITY:
FUEL/OIL MIX:
1.05 U.S. AT.
40:1
SPARK PLUG
(GAP .020 IN)
BOSCH WSR6F.
CHAMPION
RCJ-6Y
AIR VELOCITY:
229 MPH
AIR VOLUME:
589 CFM
MAXIMUM
7300 RPM
RPM:
DRY WEIGHT:
17 LBS
SERIAL NO.
DATE OF PURCHASE:
THE MODEL AND SERIAL NUMBERS WILL BE
FOUND ON A PLATE ON THE BLOWER HOUSING
ABOVE THE AIR FILTER. YOU SHOULD RECORD
BOTH SERIAL NUMBER AND DATE OF PURCHASE
AND KEEP IN A SAFE PLACE FOR FUTURE
REFERENCE.
MAINTENANCE AGREEMENT
A Sears maintenance agreement is available on this air
blower. Contactyour nearest store for details.
CUSTOMER RESPONSIBILITIES
= Read and observethe safety rules.
• Follow a regular schedule in maintaining, caring and
using your air blower.
• Follow the instructions under =Customer Responsibilities" and "Storage" sections of this manual.
WARNING: For users on U.S. ForestLand and in some
states, including California (Public Resources Codes
4442 and 4443), Idaho, Maine, Minnesota, New Jersey,
Oregon, and Washington: Certain internal combusi0n
engines operatedon forest,brush, and/or grass covered land in the above areas are required to be
equipped with a spark arrestor, maintained for the
prevention of fire..Che_k with your state or local
authorities for regulations pertaining to these requirements. Failure to follow these requirements is a violation of the law. This unit is not factory-equipped with a
spark arrestor; however; a spark arrestor is available
as an optional part. If a spark arrestor is required in
your area, contact your Sears Service Center or Parts
Department for Spark Arrestor #2048360. The spark
arrestor, blower tubes, and nozzles must be assembled
to the unit to be in full compliance with the regulations.
LIMITED ONE YEAR WARRAI_
For one (1) year from the clareof._urchaseif the Backpack Air Blower is maintained, lubdsatedand tuned up
accordingto the instructionsin tl'_'owner's manual, Sears willrepair or replace, free of charge, any partsfound to
be defective in matedal or workmanship.If this productis used commercially,this warrantyonly appliesfor 90
days.
This Warranty does not cover:
•
Expendable items which become wom dudng normal use, such as spark plugs and air filters.
•
Repairs necessary because of operator abuse, negligence, improper storage, accidentor the failure
to maintainthe equ pment according to the instructions contained in the owner's manual.
WARRANTY SERVICE IS AVAILABLE BY RETURNING THE AIR BLOWER TO THE NEAREST SEARS SERVICE CENTER IN THE UNITED STATES.
This warranty gives you specific legal rights, and you may also have other rightswhich may vary from state to
state.
SEARS, ROEBUCK AND CO., D/817 WA, HOFFMAN ESTATES, IL, 60179
ACCESSORIES
These accessoriesand attachmentswere avadablewhen the unitwas originallypurchased.They are also avadable at most Sears retailoutletsand serv=cecenters Most Sears stores can order these itemsfor you when you
providethe model numberof your unit.
2-CYCLE
AIR-COOLED
ENGINE OIL
SPARK PLUG
SAFETY
GOGGLES
GLOVES
AIR FILTER
HEARING
PROTECTION
CONTENTS
FUEL
STABILIZER
GAS CAN
OF CARTON
_,_1
Straight Tube (1)
Straight Tube (1)
(Long With Felt)
(Long)
Straight Tube (1)
Curved Nozzle Tube (1)
(Short)
Backpack Air Blower (1)
Elbow Hose (1)
CONTENTS
OF HARDWARE
PACKAGE
SEARS
OWNERS
MANUAL
METAL CLAMP
FOR ATTACHING
ELBOW
TO BLOWER HOUSING
MODEL NO.
360.796800
HOSE
(1)
PLASTIC CLAMP FOR
ATTACHING
THRO'I'I'LE
HANDLE
TO TUBE (2)
CRRFTSMRN"
4.5 HP_2 CYCLE
_mwu_
54cr./3.3
_'_ _
229 MP1"1/589 CFM
BACKPACK AIR BLOWER
¢u. in.
.C)pmw_n
FUEL FUNNEL
(1)
OWNER'S MANUAL (1)
COMBINATION WRENCH
FOR ASSEMBLY
• AND ADJUSTMENTS (1)
ASSEMBLY
READ THESE INSTRUCTIONS AND THE OPERATING MANUAL IN ITS ENTIRETY BEFORE YOU A1-FEMPT
TO ASSEMBLE OR OPERATE YOUR NEW BACKPACK AIR BLOWER.
YOUR NEW BACKPACK AIR BLOWER HAS BEEN ASSEMBLED AT THE FACTORY EXCEPT FOR THE
BLOWER TUBE. ALL NECESSARY CLAMPS TO COMPLETE ASSEMBLY AS WELL AS A COMBINATION
WRENCH ARE INCLUDED IN THE PARTS BAG ENCLOSED WITH THE UNIT.
TO ENSURE SAFE AND PROPER OPERATION OF YOUR BACKPACK AIR BLOWER, ALL CLAMPS THAT
YOU INSTALL MUST BE TIGHTENED SECURELY.
HOW TO ASSEMBLE
._""
1. Slide Metal Clamp onto the E!boc_v
Hose, then slidethe Elbow Hose over the Blower DischargePort. Move the
Oblong Clamp againstthe raisedsectionand tighten.(Fig. 1)
Elbow Hose & Clamp Assembly
(Fig. 1)
ASSEMBLY (Cont...)
2. Slide the two Round Clamps over the outletend of the Elbow Hose. The nuts on the Clamps shouldface away
from the operator. Slide the StraightTube with the felt covered end intothe ElbowHose. Place the Throttle
Handle Assemblyon the end of the Elbow Hose. The Throttle Handle Assemblyshouldbe placedsuch thatthe
ignitionswitch faces up and the throttle lever faces away from the blower. Move clamps over the metalsupport
of the Throttle Handle and tighten.Push the ThrottleCable intothe clipon the ElbowHose. (Fig, 2)
Mounting Throttle On Tube
(Fig. 2)
Throttle
Handle
Assembly
a---"
Round
Clamps
\
Elbow
Hose
Straight Tube
(Long W/Felt)
3. Attach Curved Nozzle Tube to the Straight Tube and insert securely, (Fig. 3)
Blower Hose Assembly
(Fig. 3)
Elbow Hose
Straight Tube
Straight Tube
(With Felt)
(Short Or Long)
Curved Nozzle
Tube
OPERATION
KNOW YOUR BACKPACK
AIR BLOWER
READ THIS OWNER'S MANUAL AND SAFETY INSTRUCTIONS
BEFORE OPERATING YOUR BACKPACK AIR
BLOWER Compare the tllustratJonwtth your backpack air blower to famdtanze yourself with the location of vanous
controls and adjustments. Save thts manual for future reference.
Know Your Backpack
(Fig. 4)
Air Blower
1. On/Off Switch - Turns Motor Off
2. Throttle Lever- Controls Engine Speed
3. Choke Lever - Placed In Down To Start, Up To Run.
4. Fuel Valve - Open (In Line With Fuel Line) To Run,
Closed For Storage & To Run Carburetor Dry,
5.
6.
7.
8.
9.
10.
®
Serial# Data Plate
Air Filter
Fuel Cap
Recoil Starter
Spark Plug
Muffler
r_
Handle Throttle & Lever
Choke Lever
(Fig. 5)
OrdO_witch
F
t Start (I)_Stop
IL
(O) I
iI
tA
Idle
Throttle
Lever
OPERATION
HOW
TO USE YOUR
BACKPACK
CONTINUED
AIR BLOWER
formation of acids duringstorage.
Acidic gas can damage the fuel system of an engine while
in storage. To avoid engine problems, the fuel system
should be emptied before storage for 30 days or longer.
,_ WARNING:
BE SURE TO READ THE FUEL HANDLING INFORDrain the gas tank, then run the fuel out of the carburetor
MATION IN THE SAFETY RULES SECTION ON
and fuel lines by startingthe engine and letting itrun until it
PAGE 2 OF THIS MANUAL BEFORE YOU BEGIN.
stops. Use fresh fuel next season.See STORAGE instrucIF YOU DO NOT UNDERSTAND THE FUEL HANtions for additional information. Never use engine or carDLING SECTION DO NOT AI-I'EMPT TO FUEL
buretor cleaner products in the fuel tank or permanent damYOUR UNIT; SEEK HELP FROM SOMEONE THAT
age may occur.
DOES UNDERSTAND THE FUEL HANDLING
FUEL STABILIZER
SECTION OR CALL SEARS SERVICE AT 1-800-4REPAIR.
Fuel stabilizer is an acceptable alternative in minimizing
GASOLINE
MIXTURE
the formationoffuel gum depositsduringstorage.Add stabilizerto gasolinein fuel tankor storagecontainer.Always
The two-cycle engine on this product requires a fuel
follow the fuel mix ratiofound on the stabilizercontainer.
mixture of regular unleaded gasoline and a high quality
40:1 2-cycle engine oil (AIR-COOLED) for lubrication of Run engine at least 5 minutes after adding stabilizer to
the bearings and other moving parts. The correct fuel/oil allowthe stabilizerto reachthe carburetor. You do not have
mixture is 40:1 (see Fuel Mixture Chart). Too little oil or to drainthe fuel tankfor storageifyou are usingfuel stabilizer.
the incorrect oil type will cause poor performance and
may cause the engine to overheat and seize.
2-CYCLE OIL
CRAFTSMAN 40:1 2-cycle engine oil (AIR-COOLED) is
Gasoline and oil must be premixed in a clean approved specially blended with fuel stabilizers.If you do not use
fuel container. Always use fresh regular unleaded
thisSears oil,you can add a fuel stabilizer(suchas Craftsgasoline.
man No. 33500) to your fuel mix. See =Gasoline and Oil
This engine is certified to operate on unleaded gasoline. MixtureInstructions" below.
To stop engine, move throttle lever to idle position and
turn switch to STOP.
IMPORTANT: Experience indicates that alcohol blended If CRAFTSMAN 40:1 2-Cycle engine oil is not available;
fuels called gasohol (or using ethanol or methanol} can usea good quality40:1 2-cycle engine oil(AIR-COOLED)
attract moisture, which leads to oiVgas separation and that has a recommendedfuel mix ratioof 40:1.
OPERATION CONTINUED
IMPORTANTI DO NOT USE:
• AUTOMOTIVE OIL
• BOAT OILS (NMMA, BIA. ET,G)_'_.
These oilsdo not have proper add_ivesfor 2-cycle
(AIR-COOLED) engines and cah _:_useengine
damage.
GASOLINE AND OIL MIXTURE
MIX GASOLINE AND OIL AS FOLLOWS:
• Consultchart for correctquantities.
• Do not mix gasolineand oildirectlyin the fuel
tank.
FOR ONE GALLON:
• Pdur3.2 ouncesof high quality,2-cycle engine oil
(AIR-COOLED] intoan empty, approved one gallon
gasolinecontainer.
• Add one gallonof regularunleadedgasolineto the
gallon container, then securely replacethe cap.
Shake the containermomentarily.
• The mixtureis now ready for use. Fuel stabilizer
can be added at this time if desired;follow mixing
Instructionson the label.
FUEL MIXTURE CHART
1 Gallon
I GASOLINE
2.5 Gallons
.
3.2 ounces
OIL
8.0 ounces
I
STARTING
COLD
1. Make sure that the fuel valve is in the open position.
(lever in line with the fuel line). (Fig. 4)
2.
3.
4.
5.
Move switchto the Start (I) position.(Fig. 5)
Set Throttle between the "to " position.(Fig. 5)
AdjustChoke to the Start (upward) position.
Pull Starter Cord slowlyuntil resistanceis felt. Then
pullforcibly.
6. When engine cranks (attemptsto start) movechoke
lever to the RUN (down) positionand pullstarter.
STARTING - WARM
Followcold startinginstructionsbut leave choke lever in
Rur_(down)position.
STOPPING
To stop engine, adjustThrottleto IDLE and switchto
STOP (0) positions.
CUSTOMER
MAINTENANCE
RESPONSIBILITIES
SCHEDULE
SERVICE DATES
B
L
O
W
E
R
CHECK FOR LOOSE FASTENERS
E
N
G
I
N
E
CUSTOMER
RESPONSIBILITIES
CONTINUED
GENERALRECOMMENDATIONS
TO CLEAN AIR FILTER
The warrantyon this atr blowerdoes not cover items
that have been subjectedto operatorabuse or negk-'
gence. To recetvefull value from the warranty,operator must maintainair blower as inst,
tucted m this
manual
1. Remove the air filter cover
All ttemsin the Customer Respondibditiessectionof
thtsmanual shouldbe checked at leastonce each
season
1. Service more often when operatmgin dustyor dirty
conditions.
2. Once a year you shouldreplacethe spark plug and
clean or replace the air filter. A new spark plugand
a clean air filter assures properair-fuel mtxtureand
helps your engme run better and last longer.
CHECK FOR LOOSE FASTENERS
Check all fasteners, includingnuts, bolts, screws and
clamps, to insure that they are tightand secure. If not,
make necessary adjustmentspriorto using atr blower.
AIR FILTER
Your engine will not run propenyano may De damaged by using a dirtyair filter.
Replace air filterelement if deteriorationoccurs.
Service more often If you use your Air Blowerin very
dusty ordirty conditions.
2. Rinse air filter m a mddsoap & watersolutton.
3. Dry atr filter completelyand otl slightlyby placinga
small amount of otlon the filter and kneedinguntd
completelysaturated. Wtpe off excess od. Reassemble air filter
4. Replace a=rfilter element tfdeteriorating.
MUFFLER
Inspectand replace corrodedmuffleras itcould create a
fire hazard and/or damage.
SPARK PLUG
Change your spark plug each year to make your engine
start easy and run better. Set spark plug gap at .020".
CUSTOMER
CARBURETOR
RESPONSIBILITIES
ADJUSTMENT
CONTINUED
FUEL FILTER
To comply with emission regulations, the carburetor
mixture is pre-set at the factory and can not be adjusted The idle speed can be adjusted. The idle speed
set screw ts located near the throttle cable on top of the
carburetor. To adjust idle speed'
• Loosen the Iocknuton the idle speed set screw•
• Start the blower and move throttleto idle position
• Adjustidle speed to desired speed. (Clockwiseto
increase/counterclockwiseto decrease)
• Shut offblower
T=ghtenIocknut.
Carburetor
AdJusmmt
Clean fuel filter once every season to ensure good fuel
flow to the carburetor. This makes the engine run better.
To clean: empty fuel tank, remove fuel tank, remove fuel
valve from tank by unscrewing, flush filter in a mild soap
and water solution and dry before reassembly.
ENGINE CYLINDER COOLING FINS
IMPORTANT: For best performance,keep d=rtfrom
accumulatingaroundthe engine coolingfins. Clogged
coohogfins cause the engine to run hotterand shortens
its life Coolingfins may be cleaned usinga toothbrush
or st(ffbristle brush.
SPARK ARRESTOR
1. Remove screen
SCREEN (If Installed)
2. Clean usinga wire brush and reinstall.
3 Replace ifdeteriorating.
I- FI-
"11"="
STORAGE
Prepare your Backpack Air Blower for storage at the
end of the season or ifthe unit will not be used for 30
days or more
1. Use soap and water to wipe down unitpriorto
storage.
2. Be sure that all nuts, bolts,screwS'_ndfasteners are
securelyfastened. Inspectfor d_maged or worn
parts. Replace if necessary.
3. Touch up all rustedor chippedpaintsurfaces,sand
lightlybefor_painting.
BLOWER TUBE
The straightblower tubes can be removedto ease
storage Use care not to =kink"the throttlecable.
ENGINE
FUEL SYSTEM - It is importantto preventgum depositsfrom forming in essentialfuel system parts such as
the carburetor, fuel filter, fuel hose or tankduring
storage. Also, experience indicatesthat alcohol blended
fuels (called gasoholor usingethanol or methanol)can
attract moisturewhzchleads to separationand formation of acids during storage•Acidicgas can damage the
fuel system of an engine while in storage.
To avoidengine problems,the fuel system shouldbe
emptied before storageof 30 days or longer. Follow
these instructions:
1. Drain the fuel tank.
2. Start engine and let It run untilthe fuel lines and
ca_urator are empty (engine stops).
3. Use fresh gas nextseason.
4. If you use fuel stabilizer,the gasolinecan be left in
the tank. Remember to turnthe fuel shut-offvalve to
the off positionand follow Step #2 above.
CYLINDER
1.
2.
3.
4.
Remove spark plug.
Pour a few drops of oil intothe cylinder.
Pull starter handle slowlyto distributeoil.
Replace w_thnew spark plug.
OTHER
• Do not store gasolinefrom one season to another. 2cycle mix ages quicklyand can cause engine
damage.
• Replace yourgasohne can if It startsto rust.Rust
and/or dirt in yourgasolinewill cause problems.
• If possible,store your unItindoorsand cover it to
give it protectionfrom dust and d_rt.Do not use
plastic. P.lasticcannot breathwh=chwdl allowcondensetionto form and will cause yourunIt to rust.
IMPORTANT: NEVER COVER AIR BLOWER WHILE
ENGINE AND MUFFLER ARE STILL WARM.
,_
CAUTION:
NEVER STORE YOUR AIR BLOWER INSIDE A
BUILDING WITH FUEL IN THE TANK. FUMES
CAN CONCENTRATE AND POSSIBLY REACH
•A SOURCE OF IGNmON. ALLOW ENGINE TO
COOL BEFORE STORAGE.
,-' .,. _
TROUBLE
SHOOTING
POINTS
PROBLEM
ENGINE SMOKES
EXCESSIVELY
CAUSE
CORRECTION
1. DirtyAir Filter
1. Clean or Replace Air Filter
2. Fuel Mixture Incorrect 2. Venfy you have 40"1 Fuel Mixture.
3. Carburetorrequires
3. See carburetorAdjustmentunder CustomerResponslbditle=
adjustment
ENGINE HARD TO
START, WILL NOT
START OR STARTS
AND ONLY RUNS A
FEW SECONDS
1. FuelTank Empty.
2. Engine Flooded.
3. Spark plug notfinng.
4. DirtyAir Filter
5. Carburetor requires
idle adjustment.
6 Stale fuel mixor water
in fuel mix
7. Spark plug wire
dasconnected
8. Switch in off position.
f. Fill tank with correctfuel mix.
2. Remove and clean spark plug.With spark plug removed
(engine switchedoff), crank engine a few times to remove
excess fuel from cylinder. Reinstallspark plug.
3 Check as follows: Remove spark plug and reattachthe
spark plugto the spark plugwire. Groundthe tip of the
spark plug againstthe engine and pull starter recoilhandle.
A strongwhite spark shouldjump across the plug tip. If
there is no spark or a weak spark, trythe test with a new
spark plug. If a new spark plugdoes not solve the problem,
take the unitto a Sears Service Center
4. Clean or replace air filter
5. See CarburetorAdjustmentunderCustomer Responsibilities
6. Drain tank and refillwith fresh, clean fuel mix.
7. Connect wire to plug.
8 Move switchto Run position
ENGINE WILL NOT
1. Dirtyair filter.
1. Clean or replacefilter.
ACCELERATE
2. Spark plug fouled.
2. Clean or replace spark plug and re-gap (0.020).
LACKS POWER, OR 3. (Optional) Spark
3. Clean or replace screen.
DIES UNDER A LOAD
Arrestor Screen Plugged.
4. Carburetor requires
4. See Carburetor AdjustmentunderCustomer Responsibilities
Adjustment.
Sparepartslist
150_
i
i
122
i
I
i
124
I
1354
L
,I
'l
'
127
b
130
l
114
104
®
I
I
I
121
120
116115
113
112
111
110
I
----___]
t
I
I
30
32
35
26
20
19
16
17
18
9
Reparat uPsatz- Vergaser
Repair - kit - Carburetor
Kit de rf_paratlon - Carburateur
Juego de reparation - _rburadot
I
160
Dtdltsatz - Vergaser
Gasket÷klt-Carb_etor
Pochette
deioir_- _r
1:6_I
.
,
BdcI.Nr BestelI.Nr
Pos-No, O_der-No
Pos-No NOdeCde
Pos-No Ref-Fir
1
3
5
8
9
12
15
1G
17
18
lg
2O
22
25
26
27
28
3O
32
33
35
37
38
39
40
49
5O
55
57
58
59
6O
64
65
67
G8
7O
72
74
75
7G
77
83
90
91
92
95
96
97
98
100
101
102
103
104
105
106
108
110
111
112
113
114
115
11G
120
121
122
124
127
128
138
' 133
2048369
20O83O8
2500709
00 72 140
00 28 137
23 00 747
20 61 495
20 74 913
40 35 118
00 18 338
20 61 496
0015291
21 00 456
0015158
20 61 308
2500708
O018 207
0034100
0021 130
0028137
25 O0710
00 30 125
00 72 143
0028100
00 30 125
0034201
00 10 175
23 O0730
0018188
20 43 244
0033285
0018346
20 48 357
2200812
20 31 238F
0055144
22 00 T/G
i 0052206
qoderl Merge
QuantityMotor/
ype
4od_le Hombre
_odelo Canbde( Geblise
; 007s100
0031502
0050102
0054256
O018 389
25 00 714
0030102
0018334
0084600
0073385
2300487
2300680
0084612
0084537
0072148
00 18 328
O028118
0018311
0066441
0018348
4400281
4400211
4074805
4073602
4073601
0034115
00 21 233
4400280
0010204
4074382
0018282
4073352
0018274
0064139
0062116
2
1
2
2
1
1
1
1
1
I
2
1
2
1
I
1
2
1
1
1
2
2
2
2
1
1
1
2
1
2
1
1
1
1
2
1
t
I
2
2
2
4
2
Engine/
Moteur/
Blower Housing Carter de Turbine
F_ltereinsata
filter element
Fitterplatte
filterplate
Luftiilter.kompl
a_rfilter,compl
"fellededer
5,2x12xO,5
DIN2093A
springwasbor
Sechskantmutter
MSDIN980
nut
Vergaser
WYJ-128
carburetor
WYK-128
Vergaserdtchtung
0,7mmdick
carburetor
gasket
Vergaserstutzen
manrfolri
Dtstanzrohr
10xl,8xlO
spacer
Zyhnde_hraubo
MSx25
screw
D_htungZyllnder-Vergaserstutzen_mder gasket
Sttftschraubo
M5x73
screw
filtre&air
plaquedeltltre
ftltre,_air,compl
rondelleballevtlle
ecrou
carburateur
WYJ-128
jomtdecarburateur
boded'arimtsslon
entretolse
vrs
jo=utd'admtss[on
ws
Kurbolgeh
+Zyhnder
0 45mm,komplcrankcase+cybnder,
complcartermoteuraveco/hndre
Sbftachraubo
MSx15DIN835
screw
ws
Auspuffdtchtung
1,2mmdick
Auspuff
Sechskantschraubo
M5x16
Schnorrstcborung
5
Sechskantmutter
M5
Sechskantmuttac
MSDIN980
Auspuffschutz
_helbo 6.4DIN9021
Spannsicherungsschelbo
6 DING796A
_.hskantmutter MG
Schetbo
G,4DIN9021
S_lerungsr_elbo
5
Zy[tnderschraubo
M5xl0DIN84A
ZGndkerze
WSRGF
200
Sechskantschraubo
M5x20
Befestlgungswlnkel
Dtstanzst_ck
6xlOxT,8
Zylinderschraubo
MGx16
Kolbonnug
45xl,5
KolbonO45 mm
Kolbonbolzen
10/6x32
Kotbonbolzens_cherueg
I0x0,8
Kurbelwelle
3-teihg
Nadelk&fig
10x13x14,5
Scheibonfeder
2x3,7DIN6_
PaBscheibo
26xJTxlDIN988
mufflergasket
muffler
screw
washer
nut
nut
mufflerguard
washer
tensionwasher
nut
washer
circhp
screw
sparkplug
screw
I_acket
spacer
screw
pntonring
piston
pistonpin
pistonpincirchp
crankshaft
needlebeanng
woodruffkey
washer
Motor/
Caja del Ventilador
elemento
filtrante
platadeftJtro
flltro dealre,compl
resor_e
tuerca
carburadorWYJ-128
juntadelcarburador
bndadecarburador
tuboespacFador
torntJlo
lunta
torndlo
ogGenal+ ohndro,compl
tormllo
jointd'_chappement
juntade escape
echappament
escape
vts
torndio
rondellecrant_
seguro
ecrou
tuerca
ecrou
tuerca
caputprotechon
_chappementpmtecc_ndelescape
rondelle
arandela
rondelledetension
arandela
_crou
tuerca
rondelle
acandela
rondelle_lasttque
antlloorcltp
vts
torntllo
bougle
bupa
vts
torntllo
equerredefrxatton
angulodefljaoon
eotretotse
espactador
vts
tornlllo
segment
antllodepiston
piston
piston
axede piston
boulonde piston
dipd'axede prston
segurode bulon
vdebrequm
ogOenal
roulement
&atgmlles
casqudlo
deagujas
clavet_e
demvlune
chaveta
rondelle
arandela
RiIlenkugellager
15_5xl1 DIN6202 ballbearing
roulement
&brlles
cojmetede bolas
Welle_kd_tring
15x]5x5
oil seal
JOintd'acbre
retch
Zyli_dersdlraubo
M5x45
screw
vis
torndlo
Hal_lNinkel
angle
equerredefixation
angu]odefijaoon
Sche=bo
5,3DIN9021A
washer
rondelle
arandela
Zyhndersdlraubo
M5xl0
screw
vts
torntllo
Kerzenstecker
sparkplugcap
capuchonde bougm
cabaruza
bujta
Kontaktfeder
contactspring
ressort
de contact
resortedecontacto
ZOndmodul
=gnrttoncod
bobmed'ailumage
bobma
ZO_modul,kompl
Ignittoncod,compl
bobmeallumege,compl
bobma,compl.
KurzschluBkabol,
Spule,rot
short-arcuit
cable,red c_blecourt-orcult,
rouge
cablecortoorculto,
rojo
Massekabol,
schwarz
groundcable,_ack
c_bledemasse,
notr
cablede mase,negro
Spannscboibo
4 DIN67%
tensionwasher
rondelle
d_sco
de teost_
Zyhnderschraubo
M4x25
s_ew
vts
torntllo
Sechskantrnutter
M4 DIN980
nut
_rou
tuerca
Ltn_enschraubo
6x14
screw
vts
torntilo
S_helle12J12
clamp
collier
abrazadera
Zyhnderschcaubo
M6x25
screw
vts
torntllo
GebBsegehEuso,
grau
blowerhousing,
grey
carterdeturbine,gns
carterdeturbtna,gns
Magnet-LGfterrad,
voll_nd=g
fan+flywboefassemblyturbme+volantmagn_t_queruedaventdacion
Abde_kung
cover
re;ouvrement
oJbterta
Zw_scbonflansch
2,grau
spacer2,grey
bodemterr_ta=re 2,gns
bndamtermedta2, grts
Zwlscbonflansch
1,grau
spacer1,grey
brideintermkhaire1,gns
bndaintermedta
1,gns
$d_n_rrucborueg
8
washer
rondellecrant_
seguro
Sechskan_utter
M8
nut
,k.rou
tuerca
GebBsegeh_uso
2,grau
Zyhnderschraube
M5x75DIN84 A
Deckel,grau
bnsensch_aube
5x45
kuftdurchtritt
bnsonsch_aubo
Sx16
Schlauch
5xl,5
blowerhousing
2, gr_=y carterdeturbme2, gris
screw
vts
co_, grey
oouverde,gris
screw
ws
aJrintake
grilledeprotection
screw
_
fue_hose
. tuyaq
carterdeturbtna2,gris
tornillo
tapa,gns
torndlo
pasodeaire
tomilln
:tubo,
O-Pa_
9x2
nng
:an_lio
.',joint
tod_ue
"4
45
40 41
I
I(
2
414SEARS-d/OT.98.tiff
Bild-Nr, BestdI-Nn
Pos.-No.Order-No.
i
Pos.:No.No;deCde.
Pos,-No.Ref.-Ne
I
2
3
7
10
11
12
15
17
2O
21
22
25
26
27
30
31
32
33
34
35
4O
41
45
40 71281
40 65180
40 G5173
O060159
0018340
0066399 i
0020160
4400204
O066662
4800187
2063 128
0028 121
2800338
28O0551
0064415R
O028 110
4073644
0084477
6073 567
O018356
0018364
0084704
0084703
4800199
Mndell
type
Mod61e
Mndelo
1
s
Blasrohr
Straight tube Tube de soufflerie
Tubo soplador
BlaskrOmmer
Blasrohr
60xl,3xSO0
Blasroh_P_rbindungsst
Gck60xl,3
Fil_ffage 50x195xl,5
Zyli_j_.erschraube
MSx4O
Spah_schelJe
Ggxl0
Vierkantmutter
M5DIN557
elbow
tubecoud_
stzaight
tube
tubede soufflerie
straight
tubeconnection
tubede soufflerie
feltspacer
feutrine
screw
vis
clamp
collierde serrage
nut
PJou
codosoplador
tubesoplador
conexion
de tubo
apoyodeflelvo
tomillo
abrazadera
tuerca
Faltenschlauch
Spannschelle
60/80x9
Griffrohr22xlx140
KabeltQIle
4xGRx3i6
Sechskantmottar
MG
Regulierbebel
Bewdenzug,Gas
Wellschlauch
8,5
5echskantmuttar
M5DIN980
Griff_lfte, innen
Kurzschlugschalter
Griffh_lfte,auSen
Linsenschraube
M4x2O
Zylinderschraube
M5x32
Kurzschlu6kabel,
rot
Massekabe],
schwarz
Gdff,kompl,
pleatedhosew/elbow
metalclamp
handletube
grommet
nut
throttlelever
throttlecable,gas
tube
nut
griphalf
shortcircuitbutton
griphalf
strew
screw
short<ircuit
cable,red
groundcable,black
grip,compL
tuboplegahle
abfazadera
tube
manguitodecable
tuerca
palanca
de gas
cablebowden,gas
tubo
tuerca
cascara
interruptor
r._ara
tomillo
tornillo
cablecorcodrcuito,
rojo
cablede masa,negro
cascara,€ompt.
tuyausouple+ coude
cdlierde serrage
supportde poign6e
passe-ill
_rou
manetted'acc_l_rateur
_ble d'acc61_rataur,
gaz
tube
_rou
poign_ ext_rieure
interrupteur
poign_eext_rieure
vis
vis
c,iblecourt<ircuitrouge
_ble demasse,
noir
poign_,compL
Bild-Hr. Bestell-Nr.Modell Me_e
Pos.-No.Order-No.
Quant_
Pos...Ho.No.deCde.
Nombres
Pos.,-No.Ref,-Nr. Modelo_nti_d
TypeMod Tragegestell
le
1
2
3
7
8
9
12
13
15
16
17
18
19
22
23
24
25
28
3O
4300273
4043998
50 74562
0018258
0018344
40 36414
0096 151
4074962
O012161
O033375
O073363
O018311
0028121
O012172
O073363
O018311
0028121
4074833
4300334
1
1
1
2
2
2
1
5
2
2
2
2
2
2
2
2
2
1
2
Frame
Chassis
Bastidor
Traggeste]l
Haltewinkel
Gdff,sd_warz
.Unf_chraube 5x18
°'_ind_rschraube
M6xl0
frame
topsupport
handle,black
screw
screw
chassis
_cluerrede maintien
poign_e,noir
vis
vis
bastidor
angulosoporte
palanca,negro
tornillo
tornillo
._rtbefestigung
ROdmkissen
Stopfen6xlTx18
Sechskantschraube
M6x2.S
DIN933
shouldstrapdip
backcushion
cushion
plug
screw
crochetdebretelle
coussin
dorsal
bo_'hon
vis
fijacion
almohadilla
tapon
tornillo
Distanzrohr
12x2,8x10
DEmpfungsfeder
3x22x26
t.imenschrau_6x14
Sechskantmutter
M6
Seshskantsdlraube
M6x16DIN933
D&mpfungsfeder
3x22x26
Unsenschraube
6x14
Sechskantmutter
M6
spacer
avspring
screw
nut
screw
avspring
screw
nut
entretoise
ressort
amortisseur
vis
_rou
vis
ressort
amortisseur
vis
_crou
tube
resorteamortiguador
tornirlo
tuerca
tornillo
resorteamostiguador
tomillo
tuerca
Befe_tigungshaken,
schwa_
Tragegust,
kompl,
plastic
hook,black
crochet,noir
shoulder
strap,compl, bretelle,compl,
leva,negro
cinturonportador,compl.
Bdd-Nr
Pos-No
Pos-No
Fos-No
BestelI-Nr Modell Menge
Order-No Type Quantity Motor/
No de Cde ModUle Nombres
Ref-Nr
Modelo CantldadGebl_se
134
135
140
141
142
143
145
150
155
15G
160
161
O062 144
2700340
0018275
O030 102
0094197
0044285
27 00 180
27 00 376
20 73 266
O062 127
05 10 922
05 10 923
1
1
2
2
2
2
1
1
1
1
1
1
Engine/
Moteur/
Motor/
Blower Housing Carter de Turbine
Caja del Ventilador
ring
fuelvalve,compl
screw
washer
jointtorlque
robtnetd'essence,
compl
vts
rondelle
antllo
grtfode gasohna,
compl
torntllo
arandela
D_mpfungsgumrm
7x13,5x7 shockabsorber
Rohrntet
8xO.75x7
DIN7340A rivet
stlentbloc
rtvet
gomaamorttguadora
remache
Tankverschlul3,
kompl
Benzmtank.
kompl
EmfGIItr[chter
Dtchtrtng
95xlO5x12,5
ReparatursatzVergaser
DtchtsatzVergaser
bouchon
d'essence,
compl
cterrededep/asuto,
compl
r_servotr
d'essence,
compl
deposrto
decombustible,
compl
entonnotrderemphssage
embudodeIlenado
jomtd'_tancMtt_
amllolunta
kitde r@aratJon
- carburateur juego dereparation-carburador
pochettedejoints-carburateurjuego dejuntas- carb.urador
O-Rtng
13x3
Benzinhahn,
kompl
Llnsenschraube
5x30
Schetbe
5,3D[N9021A
tankcap.compl
fueltank,compl
funnel
gasket
repair_lt-carburetor
gasket-bt-carburetor
11
22
/
e_
/
2
f
f._
J-J
17
Btld-Nr BestelI-Nr Modell
Pos,_o Order-No Type
Pos
-No NodeCde
Pos-No Ref-Nr
Modelo
1
0018257
2
21O0534
5
O031527
2600256
6
8
2074288
10
0063152
11
2074403
13
2074388
14
6074294
15
0073364
17
2600255
2O
20 12726
21
O018338
,22
4O7358O
23
0072141
Menge
Quanttty
.o ,e Nombs
Starter
Starter
Lanceur
Arranque
screw
starter
housing
washer
recoil
spring
starter
pulley
starter
rope
starter
grip
template
starter
pawl
safety
dip
starter,compl
starter
pulley
scsew
flange
washer,
vts
carterdelanceur
rondelle
ressort
derappel
pouhe
delanceur
cordedelanceur
potgn6e
delanceur
coulis_
diquetdelanceur
goupTl[e
lanceur,
compt,
podiedelancement
_
_ inte_aaire
rondelle
tomtllo
carterdearranque
arandela
resoleretroceso
rddana
cuerda
dearranque
empunadura
cohsa
_nquete
segum
arranque,
compl.
rokbna :
to_nillo '
bidaintennedia
arandda
Canttdad
Lmsenschraube
5x25
5tartergeh_u_e
Schebe
15,8x21,8xO,2xl,6
ROckzug
federka_et_e
_drofie
Startersed
4x1050
Startergnff
Kuhs_e
Starterkhnke
Federstecker
1,5
Starter,
kompl,
Ar,wurfrolle
Zylmderschraube
M5x25
Zwischenfiansch
Sd_eibe
9,2x18xO,7
DIN2093B
ERRFTSMRN°
OWNER'S
MANUAL
4.5 HI), 2 CYCLE
54cc/3.3
cu. in.
229 MPH/589
CFM
BACKPACK AIR BLOWER
MODEL NO.
360.796800
Each Backpack Air Blower has its own sedal number
The model number of the Air Blower will be found on the BlowerHousing just
above the air filter The senal number _slocated in the same place.
All parts listedherein may be orderedthroughSears, Roebuckand Co. Service
Centers and most Retail Stores
IF YOU NEED REPAIR
SERVICE OR PARTS:
REPAIR SERVICE
1-800-4-REPAIR
(1-800-473-7247)
ORDERING
PARTS
1-800-FON-PART
WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING
INFORMATION:
•
PRODUCT-"BACKPACK AIR BLOWER"
•
MODEL NUMBER- 360 796800
•
SERIAL NUMBER
•
PART NUMBER
•
PART DESCRIPTION
Your Sears merchandisehas added value when you considerthat Sears has
service centers nationwidestaffedwith Sears trained techniciansspecifically
trained on Sears products,havingthe parts, toolsand equipmentto insure that
we meet our pledge to you,we servicewhat we sell.
(1-800-366-7278)
Sears,
Part No. US9414100
Rev. 8/98
Roebuck
and
Co., Hoffman
Estates,
IL 60179
U.S.A.