Download AOC Adelpia TGL2010A Specifications

20″ LCD Color Monitor
Adelpia TGL2010A
Service
Service
Service
Horizontal Frequency
31KHz-82KHz
TABLE OF CONTENTS
Description
Page
Description
Page
Table Of Contents.......…….................……...........…........1
5.2 Electrical Block Diagram…………..……..…..….......17
Important Safety Notice.………….…..................……......2
6.Schematic……………...............................….....19
Revision List.…........................………................……......3
6.1 Main Board..............................................................19
1.Monitor Specifications…...............................………........4
6.2 Power Board....…………..........……........................24
2.LCD Monitor Description…………………………….......5
6.3 Audio Board....…………….......……........................26
3.Operation Instruction…………...............……...........6
7.PCB Layout..…………...........……...........................27
3.1 General Instructions.......................................…...........6
7.1 Main Board………..................……....................27
3.2 Control Buttons………..…….…..............……...............6
7.2 Power Board…....................……………..................30
3.3 Adjusting the Picture...........................…............8
7.3 Key Board……….....…….............……….................32
4.Input/Output Specification............……………............10
8.Maintainability………............................……….........33
4.1 Input Signal Connector......….…..……........…….........10
8.1 Equipments and Tools Requirement......……….......33
4.2 Factory Preset Display Modes........…...............11
8.2 Trouble Shooting………………................................33
4.3 Power Supply Requirement…………………………....12
9.White-Balance, Luminance adjustment.............39
4.4 Panel Specification..............………………..................13
10. Monitor Exploded View……...………………............40
5.Block Diagram…….…...................…………................15
11.BOM List…................……......................….............41
5.1 Software Flow Chart…………………….……....….......15
12. Different Parts List…………………………………….56
SAFETY NOTICE
ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE CHASSIS
AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING ELECTRONIC
EQUIPMENT CONTAINING HIGH VOLTAGES.
CAUTION: USE A SEPARATE ISOLATION TRANSFOMER FOR THIS UNIT WHEN SERVICING
1
20″ LCD Color Monitor
Important Safety Notice
Adelpia TGL2010A
Proper service and repair is important to the safe, reliable operation of all AOC Company Equipment. The service
procedures recommended by AOC and described in this service manual are effective methods of performing service
operations. Some of these service operations require the use of tools specially designed for the purpose. The special
tools should be used when and as recommended.
It is important to note that this manual contains various CAUTIONS and NOTICES which should be carefully read in
order to minimize the risk of personal injury to service personnel. The possibility exists that improper service methods
may damage the equipment. It is also important to understand that these CAUTIONS and NOTICES ARE NOT
EXHAUSTIVE. AOC could not possibly know, evaluate and advise the service trade of all conceivable ways in which
service might be done or of the possible hazardous consequences of each way. Consequently, AOC has not
undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not
recommended by AOC must first satisfy himself thoroughly that neither his safety nor the safe operation of the
equipment will be jeopardized by the service method selected.
Hereafter throughout this manual, AOC Company will be referred to as AOC.
WARNING
Use of substitute replacement parts, which do not have the same, specified safety characteristics might create shock,
fire, or other hazards.
Under no circumstances should the original design be modified or altered without written permission from AOC. AOC
assumes no liability, express or implied, arising out of any unauthorized modification of design.
Servicer assumes all liability.
FOR PRODUCTS CONTAINING LASER:
DANGER-Invisible laser radiation when open AVOID DIRECT EXPOSURE TO BEAM.
CAUTION-Use of controls or adjustments or performance of procedures other than those specified herein may result
in hazardous radiation exposure.
CAUTION -The use of optical instruments with this product will increase eye hazard.
TO ENSURE THE CONTINUED RELIABILITY OF THIS PRODUCT, USE ONLY ORIGINAL MANUFACTURER'S
REPLACEMENT PARTS, WHICH ARE LISTED WITH THEIR PART NUMBERS IN THE PARTS LIST SECTION OF
THIS SERVICE MANUAL.
Take care during handling the LCD module with backlight unit
-Must mount the module using mounting holes arranged in four corners.
-Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen.
-Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to the
panel.
-Protect the module from the ESD as it may damage the electronic circuit (C-MOS).
-Make certain that treatment person’s body is grounded through wristband.
-Do not leave the module in high temperature and in areas of high humidity for a long time.
-Avoid contact with water as it may a short circuit within the module.
-If the surface of panel becomes dirty, please wipe it off with a soft material. (Cleaning with a dirty or rough cloth may
damage the panel.)
2
20″ LCD Color Monitor
Adelpia TGL2010A
Revision List
Version
Date
Revision History
TPV Model Name
Initial Release
TA6GM1DFW1UGNP
A00
Oct-16-06
A01
Mar.-27-07
Add TPV Model in item 12
TA6CM1DFW1UGNP
A02
May.-14-07
Add TPV Model In Item 12
TA6GM1DFW1UGNC
3
20″ LCD Color Monitor
1. Monitor Specifications
Adelpia TGL2010A
Items
LCD Panel
Input
Description
Driving system
TFT Color LCD
Panel Type
LM201WE3
Size
51.1cm (20.1")
Pixel pitch
0.258mm (H) x 0.258mm (V)
Viewable angle
160(H) 160(V)
Response time (type)
5 ms
Display Color
16.7M
Contrast Ratio
800:1
White Luminance
300cd/m2
Sync. Type
H/V TTL
Input Connector
D-Sub 15pin，DVI 24pin
Input Video Signal
Analog, Digital
H-Frequency
31kHz – 82kHz
V-Frequency
56-75Hz
ON Mode
≤49W
OFF Mode
≤1W
Power Consumption
Max Dot Clock
146.25MHz
Max. Resolution
1680 x 1050
Plug & Play
VESA DDC2BTM
Power Source
100~240VAC,47~63Hz
Maximum Screen Size
Horizontal : 459.4mm
Vertical: 296.4mm
Dimensions
398.5 mm (H) x472.3 mm (W) x182 mm (D)(NO Packed)
Weight
Monitor only: 5.5 kg
Environmental
Considerations
Operating Temp: 5°C to 35°C
Storage Temp: -20°C to 60°C
Operating Humidity: 10% to 85%
4
20″ LCD Color Monitor
2. LCD Monitor Description
Adelpia TGL2010A
The LCD monitor will contain a main board, a power board, and a key board which house the flat panel control logic,
brightness control logic and DDC.
The Inverter board will drive the backlight of panel and DC-DC conversion.
Monitor Block Diagram
CCFL Drive.
Flat Panel and
CCFL Backlight
RS232 Connector
Power Board
Main Board
For white balance
adjustment in factory
mode
Key board
HOST Computer
AC-IN
100V-240V
5
Video signal, DDC
20″ LCD Color Monitor
3. Operating Instructions
Adelpia TGL2010A
3.1 General Instructions
Press the power button to turn the monitor on or off. The other control buttons are located at front panel of the
monitor. By changing these settings, the picture can be adjusted to your personal preferences.
•
The power cord should be connected.
•
Connect the video cable from the monitor to the video card.
•
Press the power button to turn on the monitor position. The power indicator will light up.
3.2 Control Buttons
6
20″ LCD Color Monitor
Adelpia TGL2010A
7
20″ LCD Color Monitor
Adelpia TGL2010A
3.3 Adjusting the Picture
THE DESCRIPTION FOR CONTROL FUNCTION:
Main Menu
Item
Main
Menu
Icon
Sub Menu
Item
Sub Menu Icon
Description
Contrast
Contrast from Digital-register.
Brightness
Backlight Adjustment
Focus
Adjust Picture Phase to reduce Horizontal-Line noise
Clock
Adjust picture Clock to reduce Vertical-Line noise.
H. Position
Adjust the horizontal position of the picture.
V. Position
Adjust the vertical position of the picture.
Luminance
Image
Setup
Image
Position
Color
Temp.
Input
Warm
N/A
Recall Warm Color Temperature from EEPROM.
Cool
N/A
Recall Cool Color Temperature from EEPROM.
sRGB
N/A
Recall sRGB Temperature from EEPROM.
User / Red
Red Gain from Digital-register.
User / Green
Green Gain Digital-register.
User / Blue
Blue Gain from Digital-register.
Analog
N/A
Select input signal from analog source (D-Sub)
Digital
N/A
Select input signal from digital source (DVI)
Select
8
20″ LCD Color Monitor
OSD Setup
Adelpia TGL2010A
H. Position
Adjust the horizontal position of the OSD.
V. Position
Adjust the vertical position of the OSD.
OSD Timeout
Adjust the OSD timeout.
Language
Language
N/A
Information
Information
N/A
Yes
N/A
Clear each old status of Auto-configuration.
No
N/A
Do not execute reset, return to main menu.
N/A
N/A
Exit OSD
Select the language you like.
Show the resolution, H/V frequency and input port of
current input timing.
Reset
Exit
9
20″ LCD Color Monitor
4. Input/Output Specification
Adelpia TGL2010A
4.1 Input Signal Connector
Pin No.
Description
Pin No.
Description
1.
Red
9.
+5V
2.
Green
10.
Logic Ground
3.
Blue
11.
NC
4.
NC
12.
DDC-Serial Data
5.
DDC-Return
13.
H-Sync
6.
R-Ground
14.
V-Sync
7.
G-Ground
15.
DDC-Serial Clock
8.
B-Ground
VGA connector
Pin No.
Description
Pin No.
Description
1.
TMDS Data 2-
13.
TMDS Data 3+
2.
TMDS Data 2+
14.
+5V Power
3.
TMDS Data 2/4 Shield
15.
Ground(for+5V)
4.
TMDS Data 4-
16.
Hot Plug Detect
5.
TMDS Data 4+
17.
TMDS Data 0-
6.
DDC Clock
18.
TMDS Data 0+
7.
DDC Data
19.
TMDS Data 0/5 Shield
8.
Analog Vertical Sync
20.
TMDS Data 5-
9.
TMDS Data 1-
21.
TMDS Data 5+
10.
TMDS Data 1+
22.
TMDS Clock Shield
11.
TMDS Data 1/3 Shield
23.
TMDS Clock +
12.
TMDS Data 3-
24.
TMDS Clock -
10
20″ LCD Color Monitor
Adelpia TGL2010A
4.2 Factory Preset Display Modes
VESA MODES
Horizontal
Mode
VGA
SVGA
XGA
SXGA
WSXGA
Resolution
Total
Vertical
Nominal
Sync
Nominal
Sync
Nominal
Frequency
Polarit
Freq.
Polari
Pixel Clock
+/- 0.5kHz
y
+/- 1 Hz
ty
(MHz)
640x480@60Hz
800 x 525
31.469
N
59.940
N
25.175
640x480@72Hz
832 x 520
37.861
N
72.809
N
31.500
640x480@75Hz
840 x 500
37.500
N
75.00
N
31.500
800x600@56Hz
1024 x 625
35.156
N/P
56.250
N/P
36.000
800x600@60Hz
1056 x 628
37.879
P
60.317
P
40.000
800x600@72Hz
1040 x 666
48.077
P
72.188
P
50.000
800x600@75Hz
1056x625
46.875
P
75.000
P
49.500
1024x768@60Hz
1344x806
48.363
N
60.004
N
65.000
1024x768@70Hz
1328x806
56.476
N
70.069
N
75.000
1024x768@75Hz
1312x800
60.023
P
75.029
P
78.750
1280x1024@60Hz
1688x1066
63.981
P
60.020
P
108.000
1280x1024@75Hz
1688x1066
79.976
P
75.025
P
135.000
1680x1050@60Hz
2240x1089
65.29
N
59.95
P
146.25
IBM MODES
Horizontal
Vertical
DOS
720x400@70Hz
900 x 449
31.469
N
70.087
P
28.322
DOS
640x350@70Hz
800 x 449
31.469
P
70.087
N
25.175
XGA
1024x768@72Hz
1304 x 798
57.515
P
72.1
P
75.000
MAC MODES
VGA
SVGA
XGA
640x480@67Hz
864x525
35.000
N
66.667
N
30.240
832x624@75Hz
1152x667
49.725
N
74.551
N
57.2832
1024x768@60Hz
1312x813
48.780
N
60.001
N
64.000
1024x768@75Hz
1328x804
60.241
N
74.927
N
80.000
11
20″ LCD Color Monitor
Adelpia TGL2010A
4.3 Power Supply Requirement
A/C Line voltage range
100 V ~ 240 V
A/C Line frequency range
50 ± 3Hz, 60 ± 3Hz
Peak surge current
< 55A peak at 240 VAC and cold starting
Leakage current
< 3.5mA
Power line surge
DC output Voltage
No advance effects (no loss of information or defect)
with a maximum of 1 half-wave missing per second
12VDC± 5％
12
20″ LCD Color Monitor
Adelpia TGL2010A
4.4 Panel Specification
LM201WE3
4.4.1 General Features
4.4.2 Optical Characteristics
13
20″ LCD Color Monitor
Adelpia TGL2010A
4.4.3 Electrical Characteristics
14
20″ LCD Color Monitor
5. Block Diagram
Adelpia TGL2010A
5.1 Software Flowing Chart
1
Y
2
3
N
4
N
5
Y
6
N
7
8
Y
9
10
N
11
Y
N
12
13
Y
Y
14
15
Y
17
18
N
19
Y
15
N
N
16
20″ LCD Color Monitor
Adelpia TGL2010A
REMARK:
1) MCU initializes.
2) Is the EPROM blank?
3) Program the EPROM by default values.
4) Get the PWM value of brightness from EPROM.
5) Is the power key pressed?
6) Clear all global flags.
7) Are the AUTO and SELECT keys pressed?
8) Enter factory mode.
9) Save the power key status into EPROM.
Turn on the LED and set it to green color.
Scalar initializes.
10) In standby mode?
11) Update the lifetime of back light.
12) Check the analog port, are they’re any signals coming?
13) Does the scalar send out an interrupt request?
14) Wake up the scalar.
15) Are there any signals coming from analog port?
16) Display "No connection Check Signal Cable" message. And go into standby mode after the message
disappears.
17) Program the scalar to be able to show the coming mode.
18) Process the OSD display.
19) Read the keyboard. Is the power key pressed?
16
20″ LCD Color Monitor
Adelpia TGL2010A
5.2 Electrical Block Diagram
5.2.1 Main Board
LCD Interface
(CN101)
Flash Memory
PM25LV010-25 SCE
Scalar TSUMU58J
(U402)
(Include MCU, ADC, OSD)
(U401)
EPR_SDA
OSD Control Interface
EPR_SCL
Digital video
RXD
signal
TXD
(CN403)
R
G
B
H
V
EEPROM
DVI
D-Sub
24LC16B
Connector
Connector
(U403)
(CN406)
(CN405)
DDC_SCL_DVI,
DB15_SDA
DDC_SDA_DVI
DB15_SCL
EEPROM
EEPROM
M24C02
M24C02
(U405)
(U404)
17
20″ LCD Color Monitor
Adelpia TGL2010A
5.2.2 Power Board
AC input
Bridge
Rectifier
and Filter
EMI filter
Transformer
Rectifier
diodes
Start Circuit: R904、R932、R933
Over
Voltage
Protect
PWM
Control IC
5V
Feedback
Circuit
12V
ON/OFF
Output
Circuit
Transformer
MOSFET
Lamp
Feedback
Circuit
Over
Voltage
PWM
Control IC
ON/OFF
Control
DIM
DIM
18
20″ LCD Color Monitor
6. Schematic
Adelpia TGL2010A
6.1 Main Board
TSUMO56J
XGA/SXGA
B3
SCHEMATIC
LVDS OUTPUT
B4
+5V
+5V
RIN
GNDR
GIN
GNDG
SOG
BIN
GNDB
HSY NC
VSY NC
DDCA_SDA
DDCA_SCL
DET_VGA
RIN
GNDR
GIN
GNDG
SOG
BIN
GNDB
HSY NC
VSY NC
DDCA_SDA
DDCA_SCL
DET_VGA
DDC_WP
R+
RG+
GB+
BCLK+
CLKDDCD_SDA
DDCD_SCL
DET_DVI
DDC_WP
R+
RG+
GB+
BCLK+
CLKDDCD_SDA
DDCD_SCL
DET_DVI
VCC1.8
VCC3.3 +5V
+12V
VCC1.8
Vcc3.3
+5V
+12V
3.INPUT
B5
PA[0..9]
PB[0..9]
PA[0..9]
PA[0..9]
PB[0..9]
PB[0..9]
+12V
VLCD
VCC1.8
VLCD
+5V
B2
on_BACKLIGHT
on_Panel
VCC3.3
+12V
on_BACKLIGHT
on_Panel
VCTRL
VCTRL
VCC1.8
+5V
Adj_BACKLIGHT
VCC3.3
5.PANEL INTERFACE
Adj_BACKLIGHT
VLCD
VLCD
Title
4.SCALER
TSUMO56J
Size
B
2.POWER
Date:
19
Document Number
Rev
A
TOP
Thursday , March 02, 2006
Sheet
1
of
5
20″ LCD Color Monitor
Adelpia TGL2010A
9
NC/100uF/16V
5
4
TP
9
9
5
4
TP
1
2
3
NC/0.1uF
5
4
8
7
6
9
8
7
6
8
7
6
5
4
5
4
9
51　1/16W
5
4
TP
FTD8
FD Mark
4.7uF/16V
FTD9
FD Mark
GS1D
Q702
PZT2907A
+12V
0.1uF
3,4
+5V
+
100　1/16W
1K　1/16W
4
CN701
1
3
5
7
9
11
2
4
6
8
10
12
BL_ON
BL_ADJ
+12V
GND
+5V
GND
R705
+5V
4.7K　1/16W
C708
R706
4
VCC3.3
NC
Q701 R707
1uF/16V
R708
VCC3.3
2K　1/16W
R704
R701
GND
C707
100uF/25V GND
+12V
GND
+5V
+5V
GND
4
LL4148
+5V
C706
VCC1.8
R703
D702
+12V
VCC1.8
+ C702
D701
FTD7
FD Mark
4
R702
1
2
3
9
C704
+
VCTRL
H3
1
2
3
C703
1
NC/0.1uF
4
H2
1
2
3
VO
H1
1
2
3
C701
+3V3
2
8
7
6
VO
8
7
6
VI
1
2
3
NC/LT1117-18
GND
3
8
7
6
SOT-223
U701
+5V
4.7K　1/16W
Adj_BACKLIGHT 4
PMBS3904
+5V
10K　1/16W
C709
+
0.1uF
CONN
C710
100uF/25V
R710
NC
R711
C711
10K　1/16W
+5V
0.1uF
Q703 R712
4.7K　1/16W
on_BACKLIGHT 4
3,4
+5V
PMBS3904
SR24
TO-263
U702
3
VCC3.3
1084-ADJ
VI
VO
2
C713
VCC3.3
4
C712
ADJ
D704
C714
+
100uF/16V
0.1uF
1
0.1uF
+3V3
+5V
+3V3
VLCD
VLCD
+5V
R714
R716
NC
R717
10K　1/10W
4
on_Panel
C718
+3V3
NC
10K　1/16W
R725 4.7K　1/16W
5
R715
R723
Q706
PMBS3904
Q704
AO3401L
10K　1/16W
Q705
PMBS3906
C715
1uF/16V
+
C717
100uF/25V
R721
0
R722
NC
R727
10K　1/16W
Title
TSUMO56J
0.1uF
Size
B
Date:
20
Document Number
Rev
A
POWER
Thursday , March 23, 2006
Sheet
2
of
5
20″ LCD Color Monitor
Adelpia TGL2010A
C432 0.047uF
56　1/16W
C433 0.047uF
FB412 0　1/16W
R436
56　1/16W
C434 0.047uF
R437
470　1/16W
C435 0.001uF
R441
100　1/16W
C436 0.047uF
R442
100　1/16W
C437 0.047uF
R443
100　1/16W
C438 0.047uF
R438
75　1/16W
D406
D403
BAV99
3
3
3
17
D404
BAV99
D405
BAV99
MLL5232B 5.6V
+5V
1
2
1
1
2
120 OHM BEAD
R446
4
SOG
4
GNDR
4
GNDG
4
GNDB
4
2,4
100　1/16W
DET_VGA 4
1K　1/10W
VSI
R447
D409
MLL5232B 5.6V
4
BIN
10K　1/16W
R445
D408
MLL5232B 5.6V
4
GIN
R444
C439 0.047uF C440 0.047uF C441 0.047uF
FB409
HSI
RIN
+5V
ESD_5V
2
R448
C442
R449
C443
2.2K　1/16W
33pF
2.2K　1/16W
220pF
1K　1/10W
D410
MLL5232B 5.6V
HSY NC
4
VSYNC
4
R450
10K　1/16W
SCL_VGA
SDA_VGA
D407
BAV70
R453
R454
100　1/16W
100　1/16W
R451 R452
U404
10K　1/16W
10K　1/16W 8
7 VCC
6 WP
5 SCL
SDA
C444
A0
A1
A2
GND
1
2
3
4
0.1uF
M24C02WMN6
D411
MLL5232B 5.6V
R471
D412
MLL5232B 5.6V
4
4
DDCA_SDA
DDCA_SCL
DDC_WP 4
+5V
DVI5V
2
10K　1/16W
R458
100　1/16W
DET_DVI
4
R455
R456
DVI5V
100　1/16W
100　1/16W
D413
BAV70
R457 10K　1/16W
3
SCL_DVI
SDA_DVI
DVI5V
HPD
11
3
19
22
D426
MLL5232B 5.6V
NC
D414
MLL5232B 5.6V
D415
MLL5232B 5.6V
D416
MLL5232B 5.6V
DAT0+
DAT0DAT1+
DAT1DAT2+
DAT2-
C445
R459
0.1uF
10K　1/16W
R462
R463
R464
R465
R466
R467
10　10　10　10　10　10　1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
B+
BG+
GR+
R-
4
4
4
4
4
4
R460 R461
U405
10K　1/16W
10K　1/16W 8
7 VCC
6 WP
5 SCL
SDA
C446
A0
A1
A2
GND
1
2
3
4
0.1uF
M24C02WMN6
4
4
DDCD_SDA
DDCD_SCL
DDC_WP 4
+5V
DCLK+
DCLK-
32
31
C448
C449
C450
C451
C452
3
D422
BAV99
3
D421
BAV99
3
D420
BAV99
3
D419
BAV99
D423
BAV99
C453
10　1/16W
10　1/16W
R473
CLK+
CLK-
4
4
NC
R470
D424
BAV99
1K　1/16W
ESD_5V
C454
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
D425
1
2
1
2
1
2
1
2
1
2
2
1
0.1uF
0.1uF
RLZ36B
Title
TSUMO56J
Size
B
1
0.1uF
1
2
2
C447
D418
BAV99
3
D417
BAV99
3
JACK DVI
3
R468
R469
2
18
17
10
9
2
1
13
12
5
4
21
20
23
24
R472
3
GND
GND
DAT0+
DAT0DAT1+
DAT1DAT2+
DAT2DAT3+
DAT3DAT4+
DAT4DAT5+
DAT5clk+
clk-
25
26
27
29
28
8
15
6
7
14
16
1
1/3shield
2/4shield
0/5shield
clk shield
PC5V
+5V
CN406
R
G
B
RGB GND
HSY NC
VSY NC
SY NC GND
DDC SCL
DDC SDA
+5V
HPD
+5V
1
16
15
56　1/16W
R435
1
14
R434
FB411 0　1/16W
2
13
FB410 0　1/16W
3
12
R440
75　1/16W
11
R439
75　1/16W
CN405
DB15
RED+
1
RED6
GREEN+
2
GREEN7
BLUE+
3
BLUE8
4
PC5V
9
PC5V
VGA_CON
5
10
Date:
21
Document Number
Rev
A
INPUT
Wednesday , March 15, 2006
Sheet
3
of
5
20″ LCD Color Monitor
Adelpia TGL2010A
AVDD_33
VDDC
AVDD_MEMPLL_33
AVDD_18
VDDP
VCC3.3
0.1uF
VCC3.3
30
REFP
NC
+5V
8
7
3
4
C417
0.1uF
C418
10uF/16V
U402 PM25LV010-25SCE
2
VDD
SDO 1
HOLD# CE# 6
WP#
SCK 5
VSS
SDI
WP
41
42
43
44
108
58
54
114
40
59
87
107
112
VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
21
AVDD_18
AVDD_MEMPLL
53
74
104
126
RSDS/LVDS/TTL
SDO
CSZ
SCK
SDI
C421 22pF
128
GPIO_P00/SAR0
GPIO_P01/SAR1
GPIO_P02/SAR2
GPIO_P03/SAR3
GPIO_P06
GPIO_P07
GPIO_P13/PWM2
GPIO_P15
GPIO_P16
XIN
X401
14.318MHz
C423 22pF
127
XOUT
VDDP
VDDP
VDDP
VDDP
BY PASS
C456
VDDP
I2C_MCL
I2C_MDA
0.1uF
5
VDDC
600 OHM
C402
0.1uF
+
C404 C405 C406
0.1uF 0.1uF 0.1uF
Q402
PMBS3904
R405
C420
0.1uF
22K　1/16W
R406
C422
0.1uF
VCC3.3 FB402
10K　1/16W
AVDD_33
600 OHM
C407
0.1uF
PB[0..9]
PB[0..9]
C414
0.1uF
5
VCC1.8 FB404
R408
Volume
2
10K　1/16W
36
51
DET_VGA 3
on_BACKLIGHT 2
73
109
C415
0.1uF
VCC3.3
R413
AVDD_18
R409
600 OHM
120　1/16W
C455
R414
10K　1/16W
0.1uF
120　1/16W
Q403
PMBS3906
on_PANEL 2
LED_A
119
120
121
122
123
124
125
R411
R418
R420
100　1/16W
100　1/16W
100　1/16W
R422
R423
4.7K　1/16W
4.7K　1/16W
Q401
PMBS3906
POWER
KEY 1
KEY 2
R419 0　1/16W
LED_G
R421
VCC3.3 FB405
AVDD_MEMPLL_33
0　1/16W
600 OHM
adj_BACKLIGHT 2
3
4
DET_DVI
C416
0.1uF
3
VCC3.3
60
65
C457
66
71
R424
R425
0.1uF
10K　1/16W 10K　1/16W
C425
39
38
R428
R429
R426
10K　1/16W
0.1uF
U403
8
R427 100　1/16W 7
100　1/16W
6
100　1/16W
5
VCC
WP
SCL
SDA
A0
A1
A2
GND
1
2
3
4
AT24C16N-10SU-2.7
GND
VCC3.3
GND
GND
GND
GND
2
PA[0..9]
GPIO_P47
GPIO_P46
GPIO_P45
GPIO_P44
GPIO_P43
GPIO_P42
50
49
48
47
46
45
R491 4.7K　1/16W
R481
R482
NC
NC
WP
R488
100　1/16W
Q405
PMBS3906
113
Re s e t
Circuit
RST
PB0
PB1
PB2
PB3
PB4
PB5
PB6
PB7
PB8
PB9
VCC1.8
C403
4.7uF/16V
Option
68
69
63
62
1
VCC
GND
U406 4.38V_G690H438T73UF
3
MODE
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
10K　1/16W
+5V
37
57
56
55
61
64
67
70
118
110
111
115
116
117
1
11
17
29
52
72
88
101
105
106
R415
89
90
91
92
93
94
95
96
97
98
99
100
C410 C411 C412 C413C419
0.1uF 0.1uF 0.1uF 0.1uF0.1uF
DDC_WP 3
PA[0..9]
VDDP
102
R407
NC
GPIO_P22/PWM1
GPIO_P24/PWM2
GPIO_P04
GPIO_P25
RST
+
VCC1.8 FB401
2
VCC3.3
R404
10K　1/16W
PA0
PA1
PA2
PA3
PA4
PA5
PA6
PA7
PA8
PA9
REFM
R487
10K　1/16W
75
76
77
78
79
80
81
82
83
84
85
86
TSUMU58J-LF MST
GPIO_P14/PWM0
R486
2
KEY _A
R483
NC
VCC3.3
C616
NC
R474
R475
3.9K　1/16W
3.9K　1/16W
KEY _AUTO
KEY 2
KEY _RIGHT
R476 1K　1/16W
KEY B
R478 1K　1/16W
R480 1.5K　1/16W
KEY 1
KEY _A
KEY _MENU
KEY _LEFT
R477 1K　1/16W
KEY C
R479 1K　1/16W
LED_G
LED_A
POWER
C426 C427 C428
C429
D401 C430
0.1uF 0.1uF 0.1uF
0.1uF
0.1uF
RLZ36B
2
31
C401
LVB4P
LVB4M
LVB3P
LVB3M
LVBCKP
LVBCKM
LVB2P
LVB2M
LVB1P
LVB1M
LVB0P
LVB0M
REXT
VCTRL
VDDP
C409
0.1uF
LVA4P
LVA4M
LVA3P
LVA3M
LVACKP
LVACKM
LVA2P
LVA2M
LVA1P
LVA1M
LVA0P
LVA0M
RX2P
RX2N
RX1P
RX1N
RX0P
RX0N
RXCKP
RXCKN
DDCD_SDA
DDCD_SCL
103
FB403
600 OHM
D402
RLZ36B
1
7
R403 390 1%
VCTRL
2
AVDD_33
RIN0P
RIN0M
GIN0P
GIN0M
SOGIN0
BIN0P
BIN0M
HSY NC0
VSY NC0
DDCA_SDA/RS232_TX
DDCA_SCL/RS232_RX
VCC3.3
C408
10uF/16V
1
9
10
12
13
15
16
18
19
5
6
3
R+
3
R3
G+
3
G3
B+
3
B3
CLK+
3
CLK3 DDCD_SDA
3 DDCD_SCL
VDDC
VDDC
VDDC
VDDC
28
27
25
24
26
23
22
32
33
34
35
3
RIN
3
GNDR
R489 R490 3
GIN
3
GNDG
10K　1/16W 10K　1/16W
3
SOG
3
BIN
3
GNDB
3
HSY NC
3
VSY NC
DDCA_SDA
DDCA_SCL
AVDD_33
AVDD_33
AVDD_33
U401
VCC3.3
3
3
8
14
20
2
CN403
KEY B
LED_G
KEY _AUTO
KEY _RIGHT
POWER
OUT-L+
OUT-L-
1
3
5
7
9
11
13
15
2
4
6
8
10
12
14
16
KEY _A
LED_A
KEY _MENU
KEY _LEFT
KEY C
OUT-R+
OUT-RTitle
CONN
TSUMU58J-LF MST
Size
C
Date:
22
Document Number
Rev
A
SCALER
Monday , October 16, 2006
Sheet
4
of
5
20″ LCD Color Monitor
Adelpia TGL2010A
VLCD
PA[0..9]
PA0
PA1
PA2
PA3
PA4
PA5
PA6
PA7
PA8
PA9
4
PB[0..9]
LVA3P
LVA3M
LVACKP
LVACKM
LVA2P
LVA2M
LVA1P
LVA1M
LVA0P
LVA0M
LVB0M
LVB1M
LVB2M
LVBCKM
LVB3M
LVA0M
LVA1M
LVA2M
LVACKM
LVA3M
RXO0RXO1RXO2RXOCRXO3RXE0RXE1RXE2RXECRXE3-
PB[0..9]
PB0
PB1
PB2
PB3
PB4
PB5
PB6
PB7
PB8
PB9
LVB3P
LVB3M
LVBCKP
LVBCKM
LVB2P
LVB2M
LVB1P
LVB1M
LVB0P
LVB0M
1
3
5
7
9
11
13
15
17
19
21
23
CN102
2
4
6
8
10
12
14
16
18
20
22
24
RXO0+
RXO1+
RXO2+
RXOC+
RXO3+
RXE0+
RXE1+
RXE2+
RXEC+
RXE3+
LVB0P
LVB1P
LVB2P
LVBCKP
LVB3P
LVA0P
LVA1P
LVA2P
LVACKP
LVA3P
LVA3P
LVA3M
LVACKP
LVACKM
LVA2P
LVA2M
LVA1P
LVA1M
CONN
LVA0P
LVA0M
LVB3P
LVB3M
LVBCKP
LVBCKM
VLCD
VLCD
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
2
LVB2P
LVB2M
LVB1P
LVB1M
LVB0P
LVB0M
31
PA[0..9]
32
4
CN101
IL-FPC-30P-1MM
Title
TSUMO56J
Size
A
Date:
23
Document Number
Rev
A
PANEL INTERFACE
Thursday , March 02, 2006
Sheet
5
of
5
20″ LCD Color Monitor
Adelpia TGL2010A
6.2 Power Board
1
R932
4.7K　1/4W
SG902
!
R933
4.7K　1/4W
C907
0.1uF
IC901
1
2
3
4
2
3
L
SPARK GAP
1
SG901
SPARK GAP
4
4
!
L902
C904
NC
C902
R904
4.7K　1/4W
Vcc
DRAIN
GND
HVS
PROTECT DRIVER
CTRL
SENSE
R905
NC
8
7
6
5
3
2
220K　1/8W
R911
1K　1/8W
L901
3
7
R921
NC
11
12
C913
NC
F903 FUSE
4A/250V
+
C916
0.1uF
470uF/16V
CN903
BRC
HIGH
IL-0.13V
OFF-0V
R922
NC
POWER X'FMR
ON-3.3V
LOW
IL-1.2V
D905
BL-C
P-ID
+12V
C927
0.1uF
SP1060
R938
10K　1/8W
2
L903
L
R912
R913
NC
1K　1/8W
22K　1/8W
C909 0.22uF/50V
R914
0.18Ω 2W
R935
100　1/4W
!
R935A
100　1/4W
+
+
C929
0.001uF C930 C914
500V X7R
R935B
100　1/4W
R924
1.5K　1/4W
ZD903
D908
4
4.7K　1/8W
680K　1/4W
C928
0.0012uF
1K　1/4W
C924
0.1uF
R927
3.6K　1/4W
R929
33K　1/4W
R926
1K　1/4W
VAR901
v aristor
Q902 NC
R928
NR901
NTCR
F901
FUSE
4.0A/250V
!
C923
0.001uF/250V
IC904
AP431VLA
C926
NC
0　1/4W
C925
NC
C921
0.0047uF/250V
LL4148WP
R937
2
3
680K　1/4W
R931
8.2K　1/8W
D909
LL4148WP
R936 NC
R925
NC
IC903
PC123X2YFZOF
!
R901
680K　1/4W
RLZ5.1B
1000uF/16V
C931 NC
1
C903
0.47uF/275V
ZD904
RLZ13B
R916
R902
GND
BRI
BL-C
P-ID
GND
+12V
+12V
GND
+5V
+5V
GND
GND
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
+5V
!
4
1
+5V
C915
4.0mH
R903
4A/250V
ZD920
NC
3
FG
R917
F905
FUSE
+12V
C932
1N 50V
2
Q901
STP10NK70ZFP
R910
R915
Q903
PMBS3904
R923
NC
D903
LL4148WP
10 1/4W
C911
1uF/25V
6
2
R909
3.3　1/4W
R907
NC
R943
1KΩ 1/4W
NC
9
10
3
C908
22uF/50V
C922
470uF/25V
D907
8
5
D902
PS102R
+
TEA1530AT
0.001uF/250V
R908
100K　2W
D901
BA159GPT
R906
NC
C901
0.001uF/250V
C906
1500pF/1KV
+
+12V
1
+
3
C905
100uF/450V
-
2
+
2
3
2
BEAD
C920
0.1uF
1
1
1
80GL20T 18T
T901
4
+
1
!
FB901
BD901
GBU408
D906
SP20150R
C919
+
For
inverter
FUSE
ZD902
RLZ13B
2
C918
+
680uF/25V 680uF/25V 680uF/25V
F902
1K　1/4W
C917
L904
L
1K　1/4W
R920
100　1/4W
R941 R942
R939 R940
1K　1/4W
C912
0.001uF
R919
100　1/4W
1K　1/4W
R918
100　1/4W
R930
2.43K　1/4W
3
Title
2
FG
Size
1
SOCKET
Document Number
B
01. POWER
Rev
G1847-1-2-X-1-061016
CN901
Date:
24
Monday , October 16, 2006
Sheet
2
1
of
3
20″ LCD Color Monitor
Adelpia TGL2010A
CN801
C801 47pF/3KV
1
2
3
4
5
C802 47pF/3KV
R805
0　1/8W
1uF/25V
C814
0.1uF/50V
C815
1
2
3
4
R810
0　1/8W
1uF/25V
4.7uF
0.001uF
S
G
S
G
D
D
D
D
8
7
6
5
2
CONN
R811
0　1/4W
R807
750K　1/4W
Q805
AM4502C-T1-PF
1 L801 4
200 mH
C817
0.047uF
R818
120K　1/10W
C819
0.47uF/16V
R822
9.1K　1/10W
C825
1U 25V
C821
220P 50V
D807
R824
36KΩ 1/10W
C824
C826
OZT1060GN
C823
100pF
OLP
200K　1/4W
D808
MLL4148
0.0056uF
0.1uF
C827
470P 50V
D809
C828
0.047uF
C829
0.0068uF
R826 39K 1/8W
R817
N.C
R829
4K7 1/8W
R832
NC
Q809
C831 4.7uF
C833
R838
0　1/8W
Q811
S
G
S
G
8
7
6
5
D
D
D
D
C838
2
9
C836 47pF/3KV
C835
15pF/6KV
CONN
4.7uF
C840
AM4502C-T1-PF
R876
NC
C841
0.001uF
D812
BAV99
0.022uF
1
D813 SB240
R870 NC
D814 SB240
D815
MLL4148
L803
2
200 mH
AM4502C-T1-PF
R847
2M　1/8W
D821
LL4148WP
C844
BRI
100P 50V
R850
180K　1/8W
D816 SB240
R871
39KΩ 1/10W
3
D817
D818
4
1
1 L804 4
200 mH
2
3
N.C
R849
200K　1/4W
MLL4148
C845
470P 50V
JP801
1 D820
R875
NC
0　1/10W
Title
Size
Date:
is power GND
02. INVERTER
Document Number
Custom
Sheet
3
1
of
N.C
3
25
3
BAV99
2
R851
4K7 1/8W
is signal GND
Rev
G1847-1-2-X-1-061016
Monday , October 16, 2006
OLP
D819
Q813
RK7002
R852
523　1/8W
240　1/4W
C860
NC
8
7
6
5
R866
R845
0　1/8W
D
D
D
D
R846
200K　1/8W
Q815
NC
S
G
S
G
R844
0　1/4W
R841
750K　1/4W
Q812
1
2
3
4
CONN
R859
750K　1/4W
R874 NC
R873
NC
CN804
1
2
C843
0.1UF/50V
P-ID
CN803
1
2
3
4
5
C834 47pF/3KV
R864
240　1/4W
1
2
3
4
R836
NC
R835
1M 1/10W
C839
0.1uF/25V
C830 47pF/3KV
4.7uF
C837
0.1UF/50V
R837
NC
PT802
POWER X'FMR
80GL20T-12-DN
6
8
R865
240　1/4W
D811 SB240
2
R834
51K　1/10W
3
RK7002
R833 220KΩ 1/10W
R839
NC
R830
523　1/8W
+
R831
NC
C832
470uF/25V
1 D810
BAV99
3
2
R827
22　1/10W
R828 NC
N.C
Q808
RK7002
R843
200K　1/4W
R820
NC
20
19
18
17
16
15
14
13
12
11
R848
750K　1/8W
R825
NC
2.2uF/16V
NDR_B
PDR_A
CT
RT
PGND
LCT
DIM
LPWM
PDR_C
NDR_D
200K　1/4W
3
R853
750K　1/8W
1
C822
CTIMR
OVP
ENA
SST
VDDA
GNDA
REF
RT1
FB
CMP
200 mH
2
R842
750K　1/4W
2
1
2
3
4
5
6
7
8
9
10
1 L802 4
R858
750K　1/4W
3
C820
NC
IC801
R819 NC
3
R854
1M5 1/4W
Q807
NC
R814
2M　1/8W
2
R857
750K　1/4W
C818
1uF/25V
R840
NC
D805
MLL4148
R812
200K　1/8W
R815
0　1/4W
D806 SB240
R823
180K　1/8W
C816
0.22uF
R813
22　1/10W
CN802
1
D803
BAV99
D804 SB240
C812
0.1UF/50V
R806
10K　1/8W
C811
0.022uF
1
ZD803
RLZ5.6B
ON-3.3V OFF-0V
9
C810
D802 SB240
C813
BL-C
2
C809
RLZ5.6B
Q803
PMBS3904
Q804
DTC144WKA
R861
240　1/4W
10K 1/10W
CONN
C808
15pF/6KV
4.7uF
R856
750K　1/8W
ZD802
R808
750K　1/4W
10K 1/10W
Q802
DTA144WKA
R804
C804 47pF/3KV
PT801
POWER X'FMR
80GL20T-12-DN
6
8
C807
R855
1M5 1/4W
R803
8
7
6
5
D
D
D
D
R862
240　1/4W
ZD801
RLZ5.6B
S
G
S
G
R860
750K　1/4W
0.1UF/50V
1
2
3
4
3
C805
R802
470　1/4W
2
R801
2.4K　1/10W
R863
240　1/4W
Q801
AM4502C-T1-PF
BEAD
R809
2
C806
4.7uF
D801 SB240
+
1
V12A
C803
470uF/25V
R816
750K　1/8W
J802
20″ LCD Color Monitor
Adelpia TGL2010A
6.3 Key Board
CN002
1
5
4
3
2
7
8
R101 75R 1/8W
1
2
SPKR_R+
SPKR_L+
GND
2
2
R102 75R 1/8W
PHONEJACK
ZD102
ZD101
2
C102
270pF
C101
270pF
CN004
CONN
GND
1
FB103
C103
NC
1
2
CN003
CONN
1
120 OHM
GND
GND
EGA10603V05A1-B
1
EGA10603V05A1-B
GND
KEY _SEL
KEY _LEFT
POWER_ KEY
KEY _RIGHT
KEY _MANU
CN001
LED_GRN
KEY _SEL
KEY _RIGHT
POWER_ KEY
LED_ORANGE
LED_GRN
GND
2
4
6
8
10
12
LED_ORANGE
KEY _MANU
KEY _LEFT
GND
1
120 OHM
FB102
2SPKR_R+
CONN
EGA10603V05A1-B
EGA10603V05A1-B
EGA10603V05A1-B
1
1
2
EGA10603V05A1-B
1
1
1
EGA10603V05A1-B
ZD109
1
SW
SW
SW
LED
EGA10603V05A1-B
2
ZD108
ZD106
2
2
DP101
2
2
2
ZD107
3
SW005
1
SW004
ZD104
SW
ZD103
SW
SW003
ZD105
2
SW002
EGA10603V05A1-B
1
2
SW001
GND
SPKR_L+1
120 OHM
FB101
1
3
5
7
9
11
GND
AOC (Top Victory) Electronics Co., Ltd.
Title
Mitsubishi 19/20W keypad
26
Size
A
Document Number
Date:
Friday , June 16, 2006
715G2127-B-MIT
Rev
B
Sheet
1
of
1
20″ LCD Color Monitor
7. PCB Layout
Adelpia TGL2010A
7.1 Main Board
27
20″ LCD Color Monitor
Adelpia TGL2010A
28
20″ LCD Color Monitor
Adelpia TGL2010A
29
20″ LCD Color Monitor
Adelpia TGL2010A
7.2 Power Board
30
20″ LCD Color Monitor
Adelpia TGL2010A
31
20″ LCD Color Monitor
Adelpia TGL2010A
7.3 Key Board
32
20″ LCD Color Monitor
8. Maintainability
Adelpia TGL2010A
8.1 Equipments and Tools Requirement
Voltmeter; Oscilloscope; Pattern Generator; DDC Tool with an IBM Compatible Computer; Alignment Tool;
LCD Color Analyzer; Service Manual; User Manual.
8.2 Trouble Shooting
8.2.1 Main Board
No Power
No power
Press power key and look
if the picture is normal
NG
Please reinsert and make sure
the AC of 100-240 is normal
NG
OK
Reinsert or check the
Adapter/Inverter section
Measure Q702 Vc out =1.8V
U702 PIN2=3.3V
NG
OK
Check CN701 or replace
Q702, U702
X401 oscillate waveforms
are normal
NG
OK
Replace U401
33
Replace X401
20″ LCD Color Monitor
Adelpia TGL2010A
No Picture (LED orange)
No picture
NG
The button if under
X401 oscillate
control
NG
Replace X401
waveform is normal
OK
OK
Check reset circuit of
U401 is normal
Measure Q702, Vc
out=1.8V; U702 PIN2=3.3V
OK
Replace U401
OK
NG
X401 oscillate
waveform is normal
Replace Q702, U702
OK
NG
Replace X401
Check HS/VS from
CN405 is normal
OK
NG
Check Correspondent
component
Replace U401
34
NG
Check Correspondent
component
20″ LCD Color Monitor
Adelpia TGL2010A
Abnormal picture
Abnormal picture
NG
The power button if
under control
NG
X401 oscillate
Replace X401
waveform is normal
OK
OK
NG
Check reset circuit of
Measure Q706 base is high
Check Correspondent
component
U401 is normal
level?
OK
Replace U401
NG
White Screen
White screen
Measure Q706 base
NG
is high level?
OK
OK
Check Correspondent
component.
X401 oscillate
waveform is normal
NG
Check Q706, Q705 are
Check reset circuit of
broken or CN101 solder?
U401 is normal
NG
NG
OK
OK
Replace U401
Replace PANEL
35
Replace X401
Check Correspondent
component.
20″ LCD Color Monitor
Adelpia TGL2010A
1.) No power
Check CN903 pin6 = 12V
NG
Check AC line volt 110V or 220V
OK
NG
Check AC input
Check the voltage of C905 (+)
NG
OK
Check bridge rectified circuit and F901 circuit
Check start voltage for the pin8 of IC901
NG
OK
Check R904, R932, R933 and Change IC901
Check the auxiliary voltage is bigger than
10V and smaller than 20V
OK
NG
1) Check IC901,D902,C908
2) Check IC903 OVP circuit
Check IC901 pin6 PWM wave
OK
NG
Check IC901
Check F902, F905, Q901, D901, T901, D908, D909, ZD903, ZD904, IC901
36
20″ LCD Color Monitor
Adelpia TGL2010A
W / LED, No Backlight
Check CN903 pin6 = 12V
NG
Check adapter or MB
OK
Check ON/OFF signal
NG
Check Interface board
OK
Check IC801 pin5=5V
NG
Change Q802 or Q803
OK
Check IC801 PIN11, 12, 19.20 have the output of square wave at short time
NG
Change IC801
OK
Check the output of Q801, Q805
NG
Change Q801, Q805
OK
Check the output of PT801, PT802
NG
Change PT801, PT802
OK
Check connecter & lamp
37
20″ LCD Color Monitor
Adelpia TGL2010A
Keypad Board
OSD is unstable or not working
N
Connect Key Pad Board
Is Key Pad Board connecting normally?
Y
N
Is Button Switch normally?
Replace Button Switch
Y
N
Is Key Pad Board normally?
Y
Check Main Board
38
Replace Key Pad Board
20″ LCD Color Monitor
9. White- Balance, Luminance Adjustment
Adelpia TGL2010A
Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment.
1. How to do the Chroma-7120 MEM. Channel setting
A. Reference to chroma 7120 user guide
B. Use “SC” key and “NEXT” key to modify x,y,Y value and use “ID” key to modify the
TEXT description Following is the procedure to do white-balance adjust
2. Setting the color temp. you want
A. MEM.CHANNEL 3 (7800K color):
7800K color temp. parameter is x = 296 ±20, y = 311 ±20, Y = 180 cd/m2 ,
B. MEM.CHANNEL 4 (6500K color):
6500K color temp. parameter is x = 313±20, y = 329 ±20, Y =180 cd/m2
3. Enter into the factory mode:
Turn on power, press the MENU button, pull out the power cord, and then plug the power cord. Then the factory OSD
will be at the left top of the panel.
4. Bias adjustment:
Set the Contrast
to 50; Adjust the Brightness
to 80.
5. Gain adjustment:
Move cursor to “-F-” and press MENU key
A. Adjust C2 (7800K) color-temperature
1. Switch the Chroma-7120 to RGB-Mode (with press “MODE” button)
2. Switch the MEM. Channel to Channel 3 (with up or down arrow on chroma 7120)
3. The LCD-indicator on chroma 7120 will show x = 296 ±20, y = 311 ±20, Y =180 cd/m2
4. Adjust the RED of color1 on factory window until chroma 7120 indicator reached the value R=100
5. Adjust the GREEN of color1 on factory window until chroma 7120 indicator reached the value G=100
6. Adjust the BLUE of color1 on factory window until chroma 7120 indicator reached the value B=100
7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±2
B. Adjust C1 (6500K) color-temperature
1. Switch the chroma-7120 to RGB-Mode (with press “MODE” button)
2. Switch the MEM.channel to Channel 4(with up or down arrow on chroma 7120)
3. The LCD-indicator on chroma 7120 will show x = 313 ±20, y = 329 ±20, Y = 180 cd/m2
4. Adjust the RED of color3 on factory window until chroma 7120 indicator reached the value R=100
5. Adjust the GREEN of color3 on factory window until chroma 7120 indicator reachedthe value G=100
6. Adjust the BLUE of color3 on factory window until chroma 7120 indicator reached the value B=100
7. Repeat above procedure (item 4, 5, 6) until chroma 7120 RGB value meet the tolerance =100±2
C. Turn the Power-button off to quit from factory mode.
39
20″ LCD Color Monitor
10. Monitor Exploded View
Adelpia TGL2010A
40
20″ LCD Color Monitor
11. BOM List
Adelpia TGL2010A
TA6GM1DFW1UGNP
Location
Part NO.
Description
002G6008500 GP
SCREW
V000
040G 152509
RECYCLE LABEL
V000
040G 152512
RECYCLE LABEL
045G 76 28 RN
PE BAG FO MANUAL/BASE
045G 88606
PE BAG FOR BASE
045G 88609 10
EPE COVER
045G 88626 8
PE BAG FOR MOUITOR
052G
1185
MIDDLE TAPE FOR CARTON
052G
1186
SMALL TAPE
052G
1207 A
ALUMINIUM TAPE
052G
1211 B
AL TAPE
089G 725HAB D1
SIGNAL CABLE 1.5M
089G415C15N IS
POWER CABLE
095G8014 16 63
WIRE HARNESS
095G8018 3535
LVDS CABLE
0M1G 130 4120 GP
CPT PANEL/MAINFRAME
0M1G 130 4120 GP
CPT PANEL/MAINFRAME
0M1G 130 6125 GP
SCREW
0M1G 330 6120 GP
3MMX6 STEEL
0M1G 340 8125 GP
SCREW
0M1G1140 6120 GP
SCREW
0M1G1730 6120 GP
M3*6 SCREW
0M1G1730 6120 GP
M3*6 SCREW
0M1G3840 8125 GP
SCREW
0Q1G 330 8120 GP
SCREW 3X8mm
0Q1G 330 8120 GP
SCREW 3X8mm
0Q1G 330 8120 GP
SCREW 3X8mm
705GQAK0B34006
20" LCD REAR COVER ASS'Y
705GQAK0F34009
BEZEL ASS'Y
705GQAK0P34011
20.1" LCD STAND-BASE ASS'Y
750GLGA1W3A11N
PANEL LCD LM201WE3-TLA1 LPL
A15G0075MT1 2
MAIN FRAME
A15G0076 2 3
IO-BRACKET
A33G0030 AS 1L 32
CABLE COVER
A85G0025 1
SHIELD
CBPC6GM1A9QAP
MAIN BOARD
KEPC6QJ1P
KEY BOARD
41
20″ LCD Color Monitor
Adelpia TGL2010A
PWPCA62GA1P
POWER BOARD
Q40G 20N972 1A
Rating label
Q40G0001972 1A
Carton label
Q40G0002972 1A
Box Sealing sticker
Q40G0002972 2A
Photo label
Q40G0002972 3A
Blank label
Q40G0002972 4A
Energy star label
Q41G2002972 1A
manual
Q44GA021 1
EPS(L)
Q44GA021 2
EPS(R)
Q44GA021972 1A
Carton
Q45G 88606 16
PE BAG FOR CLAMP
Q52G6025 13 63
MYLAR
A15G0028 1
VESA BKT
A34G0094AAYA1B
REAR COVER
A33G0060 1 1C
POWER LENS
A33G0067 AS 1L
KEY PAD
A34G0093 ASA1B 30
BEZEL
012G 394 3
RUBBER FOOT
A34G0045 ASA1B 20
BASE
A34G0046 AS 2B
STAND
A37G0007 5
HINGE
AQ1G1740 12120
SCREW
012G6051 1
RUBBER FOOOT
CN701
033G8027 12
WAFER 2*6P 2.0MM R/A
CN403
033G8027 16
WAFER 16PIN 2.0mm DIP
CN101
033G8027 24 H
CONN W TO B12P*2 P*2.0 4505-2
040G 457624 1B
LABEL-CPU
040G 45762412B
CBPC LABEL
C408
067G215V100 7N
KY50VB10-M-CC3 5*11.5MM
C712
067G215V101 4N
KY25VB100M-CC3(6.3*11)
C710
067G215V101 4N
KY25VB100M-CC3(6.3*11)
C403
067G215V470 4N
KY25VB47-M-CC3.0 5*11MM
C463
067G215V470 4N
KY25VB47-M-CC3.0 5*11MM
C702
067G215Y479 7N
LOW ESR EC 4.7 UF 50V NC
CN405
088G 35315FHSW GP
D-SUB
CN406
088G 35424F H
DVI CONNECTOR 24PIN
090G6250 1
X401
CN001
GP
HEAT SINK
093G 22 53
CRYSTAL 14.318MHzHC-49US
033G8027 12 H
PIN HEADER 2*6 R/A
42
20″ LCD Color Monitor
Adelpia TGL2010A
SW001
077G 600 1 CJ
TACT SWITCH
SW002
077G 600 1 CJ
TACT SWITCH
SW003
077G 600 1 CJ
TACT SWITCH
SW004
077G 600 1 CJ
TACT SWITCH
SW005
077G 600 1 CJ
TACT SWITCH
DP101
081G 12 1 GP
LED GP32032M/R003-ZY-33
GND1
095G 900635
WIRE HARNESS
GND2
095G 900637
WIRE HARNESS
CN801
033G8020 5D U
CONNECTOR
CN803
033G8020 5D U
CONNECTOR
CN802
033G8021 2E U
WAFER
CN804
033G8021 2E U
WAFER
040G 45762412B
CBPC LABEL
IC903
056G 139 3A
PC123Y22FZOF
IC903
056G 139 3B
PC123 Y82FZ0F
VAR901
061G 46 6
GP
TNR 10V471K
C801
065G 3J4706ET
47PF 5% 3KV TDK
C802
065G 3J4706ET
47PF 5% 3KV TDK
C804
065G 3J4706ET
47PF 5% 3KV TDK
C830
065G 3J4706ET
47PF 5% 3KV TDK
C834
065G 3J4706ET
47PF 5% 3KV TDK
C836
065G 3J4706ET
47PF 5% 3KV TDK
C808
065G 6J1506ET
15PF 5% SL 6KV
C835
065G 6J1506ET
15PF 5% SL 6KV
C923
065G306M1022BM GP
Y1.CAP.001UF 250VAC MURATA
C902
065G306M1022BM GP
Y1.CAP.001UF 250VAC MURATA
C901
065G306M1022BM GP
Y1.CAP.001UF 250VAC MURATA
C921
065G306M4722BM GP
4700PF +-20% 400VAC
C915
067G215B471 3N GP
KY16VB470M-L 8*15MM
C915
067G215B471 3R
LOW E.S.R 470UF +/-20% 16V
C919
067G215B681 4R GP
EC 105℃ 680UF M 25V YXG SERIES 10*20MM
C918
067G215B681 4R GP
EC 105℃ 680UF M 25V YXG SERIES 10*20MM
C917
067G215B681 4R GP
EC 105℃ 680UF M 25V YXG SERIES 10*20MM
C914
067G215H102 3R
LOW E.S.R 1000UF +/-20% 16V
C930
067G215H102 3R
LOW E.S.R 1000UF +/-20% 16V
C914
067G215L102 3N
KY16VB1000M-L 10*16
C930
067G215L102 3N
KY16VB1000M-L 10*16
C922
067G215L471 4N
KY25VB470M-L10*16
C922
067G215L471 4R
OW E.S.R 470UF +/-20% 25V
C803
067G215Y4714NL
EC 470uF 25V 8*20mm
43
20″ LCD Color Monitor
Adelpia TGL2010A
C832
067G215Y4714NL
EC 470uF 25V 8*20mm
FB901
071G 55 23 S
BEAD
L801
073G 174 35YSA
FILTER
L802
073G 174 35YSA
FILTER
L803
073G 174 35YSA
FILTER
L804
073G 174 35YSA
FILTER
L904
073G 253 91 L
CHOKE BY LI TA
L903
073G 253 91 L
CHOKE BY LI TA
L904
073G 253 91 T
CHOKE
L903
073G 253 91 T
CHOKE
L904
073G 253 91 LS
CHOKE BY LI SHIN
L903
073G 253 91 LS
CHOKE BY LI SHIN
L902
073L 174 40LSG
LINE FILTER
L901
073L 174 50 LR
CHOKE COIL
PT802
080GL20T 12 DN
X'FMR
PT801
080GL20T 12 DN
X'FMR
T901
080GL20T 18 T
XFMR FOR POWER TDK
CN901
087G 501 37 S
AC INLET ST-01DG-B2K-K
BD901
093G 50460900
BRIDEGE DIODE GBU408 LITEON
D901
093G1100 1052T
BA159G
CN903
095G8013 13 7
WIRE HARNESS
NR901
705G 201 61 01
NR901 ASS'Y
705GQAK0 57006
Q901 ASS'Y
705GQAK0 61003
R908 ASS'Y
705GQAK0 61004
R914 ASS'Y
705GQAK0 93006
D905 ASS'Y
705GQAK0 93007
D906/D907 AS'Y
705GQAK0 95006
J904 ASS'Y
H4
A15G0114 1
EMI-BKT
U401
056G 562136
IC TSUMU58J-LF MST
U702
056G 563 7
AIC1084-33PM
U406
056G 643 20
IC RESET-4.38V-G690H438T73UF-SOT-23 GMT
U405
056G1133 34
M24C02-WMN6TP
U404
056G1133 34
M24C02-WMN6TP
U403
056G1133 56
M24C16-WMN6TP
U402
056G1133 63
IC PM25LV010-25 SCE SOIC-8 PMC
U403
056G113356A
24LC16B/SNG SOIC-8PIN
Q402
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q701
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q703
057G 417 4
PMBS3904/PHILIPS-SMT(04)
R908
44
20″ LCD Color Monitor
Adelpia TGL2010A
Q705
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q706
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q401
057G 417 6
PMBS3906/PHILIPS-SMT(06)
Q403
057G 417 6
PMBS3906/PHILIPS-SMT(06)
Q405
057G 417 6
PMBS3906/PHILIPS-SMT(06)
Q702
057G 417 17 T
PZT2907A
Q702
057G 417 23 T
TRA PZT2907AT1G SOT-223
Q702
057G 41717B T
tra PZT2907A PHILIPS
Q704
057G 763 1
A03401 SOT23 BY AOS(A1)
R728
061G0603000
RST CHIPR 0 OHM +-5% 1/10W
R721
061G0603000
RST CHIPR 0 OHM +-5% 1/10W
R421
061G0603000
RST CHIPR 0 OHM +-5% 1/10W
R419
061G0603000
RST CHIPR 0 OHM +-5% 1/10W
R469
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R462
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R463
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R464
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R465
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R466
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R467
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R468
061G0603100
RST CHIPR 10 OHM +-5% 1/10W
R476
061G0603100 1F
RST CHIPR 1 KOHM +-1% 1/10W
R477
061G0603100 1F
RST CHIPR 1 KOHM +-1% 1/10W
R479
061G0603100 1F
RST CHIPR 1 KOHM +-1% 1/10W
R478
061G0603100 1F
RST CHIPR 1 KOHM +-1% 1/10W
R428
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R427
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R420
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R418
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R411
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R429
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R441
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R442
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R443
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R445
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R453
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R454
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R455
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R456
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R458
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
45
20″ LCD Color Monitor
Adelpia TGL2010A
R488
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R704
061G0603101
RST CHIPR 100 OHM +-5% 1/10W
R447
061G0603102
RST CHIP 1K 1/10W 5%
R470
061G0603102
RST CHIP 1K 1/10W 5%
R492
061G0603102
RST CHIP 1K 1/10W 5%
R701
061G0603102
RST CHIP 1K 1/10W 5%
R408
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R413
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R415
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R424
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R425
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R426
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R444
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R471
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R487
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R489
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R490
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R708
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R711
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R714
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R717
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R729
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R406
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R409
061G0603121
RST CHIPR 120 OHM +-5% 1/10W
R414
061G0603121
RST CHIPR 120 OHM +-5% 1/10W
R480
061G0603150 1F
RST CHIPR 1.5 KOHM +-1% 1/10W
R709
061G0603153
RST CHIPR 15KOHM +-5% 1/10W
R703
061G0603202
RST CHIPR 2 KOHM +-5% 1/10W
R494
061G0603220
RST CHIPR 22 OHM +-5% 1/10W
R495
061G0603220
RST CHIPR 22 OHM +-5% 1/10W
R446
061G0603221
RST CHIPR 220 OHM +-5% 1/10W
R448
061G0603222
RST CHIPR 2.2 KOHM +-5% 1/10W
R449
061G0603222
RST CHIPR 2.2 KOHM +-5% 1/10W
R403
061G0603390 0F
RST CHIPR 390 OHM +-1% 1/10W
R474
061G0603392
RST CHIPR 3.9 KOHM +-5% 1/10W
R475
061G0603392
RST CHIPR 3.9 KOHM +-5% 1/10W
R493
061G0603470
RST CHIPR 47 OHM +-5% 1/10W
R437
061G0603471
RST CHIPR 470 OHM +-5% 1/10W
R725
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R405
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
46
20″ LCD Color Monitor
Adelpia TGL2010A
R422
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R423
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R450
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R451
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R452
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R457
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R459
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R460
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R461
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R491
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R705
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R707
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R712
061G0603472
RST CHIPR 4.7KOHM +-5% 1/10W
R702
061G0603510
RST CHIPR 51 OHM +-5% 1/10W
R723
061G0603513
RST CHIPR 51 KOHM +-5% 1/10W
R436
061G0603560
RST CHIPR 56 OHM +-5% 1/10W
R435
061G0603560
RST CHIPR 56 OHM +-5% 1/10W
R434
061G0603560
RST CHIPR 56 OHM +-5% 1/10W
R440
061G0603750
RST CHIPR 75 OHM +-5% 1/10W
R439
061G0603750
RST CHIPR 75 OHM +-5% 1/10W
R438
061G0603750
RST CHIPR 75 OHM +-5% 1/10W
R726
061G1206151
RST CHIPR 150 OHM +-5% 1/4W
R720
061G1206151
RST CHIPR 150 OHM +-5% 1/4W
C423
065G0603100 31
CHIP 10PF+-0.5PF 50V NPO
C421
065G0603100 31
CHIP 10PF+-0.5PF 50V NPO
C435
065G0603102 32
1000PF +-10% 50V X7R
C450
065G0603104 32
CHIP 0.1UF 50V X7R
C449
065G0603104 32
CHIP 0.1UF 50V X7R
C448
065G0603104 32
CHIP 0.1UF 50V X7R
C447
065G0603104 32
CHIP 0.1UF 50V X7R
C445
065G0603104 32
CHIP 0.1UF 50V X7R
C430
065G0603104 32
CHIP 0.1UF 50V X7R
C429
065G0603104 32
CHIP 0.1UF 50V X7R
C428
065G0603104 32
CHIP 0.1UF 50V X7R
C427
065G0603104 32
CHIP 0.1UF 50V X7R
C426
065G0603104 32
CHIP 0.1UF 50V X7R
C425
065G0603104 32
CHIP 0.1UF 50V X7R
C422
065G0603104 32
CHIP 0.1UF 50V X7R
C420
065G0603104 32
CHIP 0.1UF 50V X7R
C419
065G0603104 32
CHIP 0.1UF 50V X7R
47
20″ LCD Color Monitor
Adelpia TGL2010A
C456
065G0603104 32
CHIP 0.1UF 50V X7R
C454
065G0603104 32
CHIP 0.1UF 50V X7R
C453
065G0603104 32
CHIP 0.1UF 50V X7R
C452
065G0603104 32
CHIP 0.1UF 50V X7R
C451
065G0603104 32
CHIP 0.1UF 50V X7R
C459
065G0603104 32
CHIP 0.1UF 50V X7R
C460
065G0603104 32
CHIP 0.1UF 50V X7R
C461
065G0603104 32
CHIP 0.1UF 50V X7R
C709
065G0603104 32
CHIP 0.1UF 50V X7R
C711
065G0603104 32
CHIP 0.1UF 50V X7R
C713
065G0603104 32
CHIP 0.1UF 50V X7R
C714
065G0603104 32
CHIP 0.1UF 50V X7R
C718
065G0603104 32
CHIP 0.1UF 50V X7R
C457
065G0603104 32
CHIP 0.1UF 50V X7R
C458
065G0603104 32
CHIP 0.1UF 50V X7R
C455
065G0603104 32
CHIP 0.1UF 50V X7R
C417
065G0603104 32
CHIP 0.1UF 50V X7R
C401
065G0603104 32
CHIP 0.1UF 50V X7R
C402
065G0603104 32
CHIP 0.1UF 50V X7R
C404
065G0603104 32
CHIP 0.1UF 50V X7R
C405
065G0603104 32
CHIP 0.1UF 50V X7R
C406
065G0603104 32
CHIP 0.1UF 50V X7R
C407
065G0603104 32
CHIP 0.1UF 50V X7R
C409
065G0603104 32
CHIP 0.1UF 50V X7R
C416
065G0603104 32
CHIP 0.1UF 50V X7R
C415
065G0603104 32
CHIP 0.1UF 50V X7R
C414
065G0603104 32
CHIP 0.1UF 50V X7R
C413
065G0603104 32
CHIP 0.1UF 50V X7R
C412
065G0603104 32
CHIP 0.1UF 50V X7R
C411
065G0603104 32
CHIP 0.1UF 50V X7R
C410
065G0603104 32
CHIP 0.1UF 50V X7R
C444
065G0603105 12
CHIP 1UF 16VX7R 0603
C446
065G0603105 12
CHIP 1UF 16VX7R 0603
C443
065G0603221 32
CHIP 220PF 50V X7R
C715
065G0603223 32
CHIP 0.022UF 50V X7R 0603
C719
065G0603224 22
CHIP 0.22UF 25V X7R
C442
065G0603330 31
CER1 0603 NP0 50V 33P PM
C432
065G0603473 32
CHIP 0.047UF 50V X7R
C433
065G0603473 32
CHIP 0.047UF 50V X7R
C434
065G0603473 32
CHIP 0.047UF 50V X7R
48
20″ LCD Color Monitor
Adelpia TGL2010A
C436
065G0603473 32
CHIP 0.047UF 50V X7R
C437
065G0603473 32
CHIP 0.047UF 50V X7R
C438
065G0603473 32
CHIP 0.047UF 50V X7R
C439
065G0603473 32
CHIP 0.047UF 50V X7R
C440
065G0603473 32
CHIP 0.047UF 50V X7R
C441
065G0603473 32
CHIP 0.047UF 50V X7R
FB403
071G 56K121 M
CHIP BEAD
FB402
071G 56K121 M
CHIP BEAD
FB401
071G 56K121 M
CHIP BEAD
L703
071G 56K121 M
CHIP BEAD
L702
071G 56K121 M
CHIP BEAD
FB404
071G 56K121 M
CHIP BEAD
FB405
071G 56K121 M
CHIP BEAD
FB409
071G 59B431
BK1608 HW 431
FB410
071G 59C300
CHIP BEAD
FB411
071G 59C300
CHIP BEAD
FB412
071G 59C300
CHIP BEAD
D406
093G 39149
MLL5232B BY FULL POWER SMT
D408
093G 39149
MLL5232B BY FULL POWER SMT
D409
093G 39149
MLL5232B BY FULL POWER SMT
D410
093G 39149
MLL5232B BY FULL POWER SMT
D411
093G 39149
MLL5232B BY FULL POWER SMT
D412
093G 39149
MLL5232B BY FULL POWER SMT
D414
093G 39149
MLL5232B BY FULL POWER SMT
D415
093G 39149
MLL5232B BY FULL POWER SMT
D416
093G 39149
MLL5232B BY FULL POWER SMT
D426
093G 39149
MLL5232B BY FULL POWER SMT
D407
093G 64 42 P
BAV70 SOT-23
D413
093G 64 42 P
BAV70 SOT-23
D403
093G 6433P
BAV99
D404
093G 6433P
BAV99
D405
093G 6433P
BAV99
D417
093G 6433P
BAV99
D418
093G 6433P
BAV99
D419
093G 6433P
BAV99
D420
093G 6433P
BAV99
D421
093G 6433P
BAV99
D422
093G 6433P
BAV99
D423
093G 6433P
BAV99
D424
093G 6433P
BAV99
49
20″ LCD Color Monitor
Adelpia TGL2010A
D401
093G 39S 45 T
DIODE ZENER RLZ36B ROHM
D402
093G 39S 45 T
DIODE ZENER RLZ36B ROHM
D425
093G 39S 45 T
DIODE ZENER RLZ36B ROHM
D428
093G 39S 45 T
DIODE ZENER RLZ36B ROHM
D701
093G1020 1 S
GS1D
D702
093G1020 1 S
GS1D
D704
093G2004 2
SR24/PANJIT-SMT
715G2069 1 2
MAIN BOARD PCB
ZD107
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD108
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD109
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD105
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD106
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD104
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
ZD103
093G 64 49 SU
DIODE ESD EGA 10603V05A1-B INPAQ
715G2127 1FSC
KEY BOARD PCB
061G 5810T
RST NTCR 8 OHM +-20% 4A 13mm THINKING
096G 29 10
H.S. TUBE
Q901
057G 667 21
STP10NK70ZFP
HS1
090G6241 1
NR901
GP
HEAT SINK
0M1G1730 8120
SCREW
061G152M10458G
100K OHM 5% 2W
096G 29 6
H.S. TUBE
061G152M18858F
0.18OHM 2W 5% MOF
096G 29 6
H.S. TUBE
D905
093G 60235
FCQ10A06(F10P06Q)
D905
093G 60278
DIODE SP1060 ITO-220 SECOS
0M1G1730 8120
SCREW
HS3
Q90G0012 3
HEAT SINK
D906
093G 60256
DIODE
D906
093G 60281
DIODE SP20150R ITO-220 SECOS
0M1G1730 10120
SCREW
Q90G0007 1
HEAT
096G 29 1
SHRINK TUBE UL/CSA
IC901
056G 379 71
IC TEA1530AT SO-8 PHILIPS
IC801
056G 608 7
OZT1060GN SOIC-20
Q803
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q903
057G 417 4
PMBS3904/PHILIPS-SMT(04)
Q801
057G 600 61
AM4502C-TI-PF S0-8
Q805
057G 600 61
AM4502C-TI-PF S0-8
R908
R914
HS2
50
SINK
20″ LCD Color Monitor
Adelpia TGL2010A
Q811
057G 600 61
AM4502C-TI-PF S0-8
Q812
057G 600 61
AM4502C-TI-PF S0-8
Q808
057G 759 2
RK7002
Q809
057G 759 2
RK7002
Q813
057G 759 2
RK7002
Q802
057G 760 4
DTA144WKA BY ROHM SMT
Q804
057G 760 5
DTC144WKA BY ROHM SMT
JP801
061G0603000
RST CHIPR 0 OHM +-5% 1/10W
R803
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R804
061G0603103
RST CHIPR 10 KOHM +-5% 1/10W
R835
061G0603105
RST CHIPR 1 MOHM +-5% 1/10W
R818
061G0603124
RST CHIPR 120 KOHM +-5% 1/10W
R827
061G0603220
RST CHIPR 22 OHM +-5% 1/10W
R813
061G0603220
RST CHIPR 22 OHM +-5% 1/10W
R833
061G0603220 3F
RST CHIPR 220KOHM +-1% 1/10W
R801
061G0603242
RST CHIPR 2.4 KOHM +-5% 1/10W
R824
061G0603360 2F
RST CHIPR 36 KOHM +-1% 1/10W
R871
061G0603390 2F
RST CHIPR 39 KOHM +-1% 1/10W
R834
061G0603510 2F
RST CHIPR 51 KOHM +-1% 1/10W
R822
061G0603912
RST CHIPR 9.1 KOHM +-5% 1/10W
R805
061G0805000
0 OHM 1/10W
R810
061G0805000
0 OHM 1/10W
R838
061G0805000
0 OHM 1/10W
R845
061G0805000
0 OHM 1/10W
R806
061G0805100 2F
RST CHIPR 10KOHM +-1% 1/8W
R911
061G0805102
CHIP 1KOHM 1/10W
R917
061G0805102
CHIP 1KOHM 1/10W
R938
061G0805103
10 KOHM 1/10W
R823
061G0805184
RST CHIPR 180 KOHM +-5% 1/8W
R850
061G0805184
RST CHIPR 180 KOHM +-5% 1/8W
R812
061G0805204
RST CHIPR 200 KOHM +-5% 1/8W
R846
061G0805204
RST CHIPR 200 KOHM +-5% 1/8W
R814
061G0805205
RST CHIPR 2 MOHM +-5% 1/8W
R915
061G0805220 3F
RST CHIPR 220KOHM +-1% 1/8W
R912
061G0805223
RST CHIPR 22 KOHM +-5% 1/8W
R826
061G0805390 2F
RST CHIPR 39 KOHM +-1% 1/8W
R916
061G0805472
RST CHIPR 4.7 KOHM +-5% 1/8W
R851
061G0805472
RST CHIPR 4.7 KOHM +-5% 1/8W
R829
061G0805472
RST CHIPR 4.7 KOHM +-5% 1/8W
R852
061G0805523 0F
RST CHIPR 523 OHM +-1% 1/8W
51
20″ LCD Color Monitor
Adelpia TGL2010A
R830
061G0805523 0F
RST CHIPR 523 OHM +-1% 1/8W
R856
061G0805754
RST CHIPR 750 KOHM +-5% 1/8W
R853
061G0805754
RST CHIPR 750 KOHM +-5% 1/8W
R848
061G0805754
RST CHIPR 750 KOHM +-5% 1/8W
R816
061G0805754
RST CHIPR 750 KOHM +-5% 1/8W
R931
061G0805822
RST CHIPR 8.2 KOHM +-5% 1/8W
R811
061G1206000
0 OHM 1/8W
R815
061G1206000
0 OHM 1/8W
R844
061G1206000
0 OHM 1/8W
R928
061G1206000
0 OHM 1/8W
RJ801
061G1206000
0 OHM 1/8W
RJ802
061G1206000
0 OHM 1/8W
RJ803
061G1206000
0 OHM 1/8W
RJ804
061G1206000
0 OHM 1/8W
RJ806
061G1206000
0 OHM 1/8W
R910
061G1206100
10 OHM 1/8W
R918
061G1206101
100 1206
R919
061G1206101
100 1206
R920
061G1206101
100 1206
R935
061G1206101
100 1206
R935B
061G1206101
100 1206
R935A
061G1206101
100 1206
R937
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R942
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R941
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R940
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R939
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R926
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R943
061G1206102
RST CHIPR 1 KOHM +-5% 1/4W
R924
061G1206152
RST CHIPR 1.5 KOHM +-5% 1/4W
R854
061G1206155
RST CHIPR 1.5 MOHM +-5% 1/4W
R855
061G1206155
RST CHIPR 1.5 MOHM +-5% 1/4W
R809
061G1206204
RST CHIPR 200 KOHM +-5% 1/4W
R817
061G1206204
RST CHIPR 200 KOHM +-5% 1/4W
R849
061G1206204
RST CHIPR 200 KOHM +-5% 1/4W
R843
061G1206204
RST CHIPR 200 KOHM +-5% 1/4W
R847
061G1206205
RST CHIPR 2 MOHM +-5% 1/4W
R866
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
R865
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
R864
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
52
20″ LCD Color Monitor
Adelpia TGL2010A
R863
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
R862
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
R861
061G1206241
RST CHIPR 240 OHM +-5% 1/4W
R930
061G1206243 1F
RST CHIPR 2.43KOHM +-1% 1/4W
R929
061G1206333
RST CHIPR 33 KOHM +-5% 1/4W
R909
061G1206339
3.3 1206
R927
061G1206360 1F
RST CHIPR 3.6 KOHM +-1% 1/4W
R802
061G1206471
470 1206
R932
061G1206472
RST CHIPR 4.7 KOHM +-5% 1/4W
R904
061G1206472
RST CHIPR 4.7 KOHM +-5% 1/4W
R933
061G1206472
RST CHIPR 4.7 KOHM +-5% 1/4W
R901
061G1206684
RST CHIPR 680 KOHM +-5% 1/4W
R902
061G1206684
RST CHIPR 680 KOHM +-5% 1/4W
R903
061G1206684
RST CHIPR 680 KOHM +-5% 1/4W
R807
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R808
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R841
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R842
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R858
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R859
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R860
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
R857
061G1206754
RST CHIPR 750 KOHM +-5% 1/4W
C811
065G0603102 31
CHIP 1000PF 50V NPO
C841
065G0603102 31
CHIP 1000PF 50V NPO
C839
065G0603104 22
CHIP 0.1UF 25V X7R
C826
065G0603104 32
CHIP 0.1UF 50V X7R
C814
065G0603104 32
CHIP 0.1UF 50V X7R
C825
065G0603105 22
CHIP 1UF 25V X7R 0603
C818
065G0603105 22
CHIP 1UF 25V X7R 0603
C815
065G0603105 22
CHIP 1UF 25V X7R 0603
C813
065G0603105 22
CHIP 1UF 25V X7R 0603
C821
065G0603221 31
CER1 0603 NP0 50V 220P P
C840
065G0603223 32
CHIP 0.022UF 50V X7R 0603
C810
065G0603223 32
CHIP 0.022UF 50V X7R 0603
C816
065G0603224 32
CHIP 0.22UF 50V X7R
C828
065G0603473 32
CHIP 0.047UF 50V X7R
C817
065G0603473 32
CHIP 0.047UF 50V X7R
C819
065G0603474 12
MLCC 0603 0.47UF K 16V X7R
C824
065G0603562 32
CHIP 5.6NF 50V X7R
C829
065G0603682 32
CHIP 0.0068UF 50V X7R 0603
53
20″ LCD Color Monitor
Adelpia TGL2010A
C823
065G0805101 32
100PF +-10% 50V X7R
C844
065G0805101 32
100PF +-10% 50V X7R
C932
065G0805102 32
CHIP 1000P 50VX7R 0805
C805
065G0805104 32
CHIP 0.1U 50V X7R
C812
065G0805104 32
CHIP 0.1U 50V X7R
C837
065G0805104 32
CHIP 0.1U 50V X7R
C843
065G0805104 32
CHIP 0.1U 50V X7R
C907
065G0805104 32
CHIP 0.1U 50V X7R
C916
065G0805104 32
CHIP 0.1U 50V X7R
C920
065G0805104 32
CHIP 0.1U 50V X7R
C924
065G0805104 32
CHIP 0.1U 50V X7R
C927
065G0805104 32
CHIP 0.1U 50V X7R
C911
065G0805105 22
CHIP 1UF 25V X7R 0805
C928
065G0805122 31
CHIP CAP 0805 1200PF J 50V NPO
C909
065G0805224 32
0.22UF,K,50V,X7R
C822
065G0805225 22
CHIP 2.2UF 25V X7R 0805
C827
065G0805471 31
CHIP 470PF 50V NPO
C845
065G0805471 31
CHIP 470PF 50V NPO
C912
065G1206102 72
CHIP 1000PF 500V X7R
C929
065G1206102 72
CHIP 1000PF 500V X7R
C806
065G1206475 22
4.7U/25V X7R
C807
065G1206475 22
4.7U/25V X7R
C809
065G1206475 22
4.7U/25V X7R
C831
065G1206475 22
4.7U/25V X7R
C833
065G1206475 22
4.7U/25V X7R
C838
065G1206475 22
4.7U/25V X7R
R934
071G 56D121
B201209D121TT
F902
084G 52 2
SMT 4A 32V
D909
093G 64 44 S
LL4148WP
D908
093G 64 44 S
LL4148WP
D903
093G 64 44 S
LL4148WP
D821
093G 64 44 S
LL4148WP
D818
093G 64 44 S
LL4148WP
D815
093G 64 44 S
LL4148WP
D808
093G 64 44 S
LL4148WP
D805
093G 64 44 S
LL4148WP
D803
093G 6433P
BAV99
D810
093G 6433P
BAV99
D812
093G 6433P
BAV99
D820
093G 6433P
BAV99
54
20″ LCD Color Monitor
Adelpia TGL2010A
ZD801
093G 39S 24 T
RLZ 5.6B LLDS
ZD802
093G 39S 24 T
RLZ 5.6B LLDS
ZD803
093G 39S 24 T
RLZ 5.6B LLDS
ZD904
093G 39S 25 T
RLZ5.1B LLDS
ZD902
093G 39S 40 T
RLZ 13B LLDS
ZD903
093G 39S 40 T
RLZ 13B LLDS
PWA62GA1AIP
AI ASS'Y
CN901
006G 31500
EYELET
C905
006G 31502
1.5MM RIVET
NR901
006G 31502
1.5MM RIVET
PT801
006G 31502
1.5MM RIVET
PT802
006G 31502
1.5MM RIVET
Q901
006G 31502
1.5MM RIVET
T901
006G 31502
1.5MM RIVET
FB901
006G 31502
1.5MM RIVET
IC904
056G 158 7
AP431V TO-92BY ATC
IC904
056G 158 10 T
IC AZ431AZ-AE1 TO-92 BY AAC
SG901
062G 10 18 BL
SPARK GAP
SG902
062G 10 18 BL
SPARK GAP
C906
065G 1K152 1T
1.5NF/1KV Z5F+-10%
C908
067G 2152207NT
KY50VB22M-TP5 5*11
C908
067G 2152207RT
LOW E.S.R 22UF +/-20% 50V
J802
071G 55 19 T
FERRITE BEAD D9X3. 5X0.8
J905
071G 55 29
FERRITE BEAD
F901
084G 55 1
FUSE 4A 250V CONQUER
F903
084G 56 4W
FUSE 4.0A 250V
F905
084G 56 4W
FUSE 4.0A 250V
D816
093G 521ZJ26T
SB240
D814
093G 521ZJ26T
SB240
D813
093G 521ZJ26T
SB240
D811
093G 521ZJ26T
SB240
D806
093G 521ZJ26T
SB240
D804
093G 521ZJ26T
SB240
D802
093G 521ZJ26T
SB240
D801
093G 521ZJ26T
SB240
D902
093G 6038P52T
PS102R
715G1847 1 2
POWER BOARD PCB
55
20″ LCD Color Monitor
Adelpia TGL2010A
12. Different Parts List
Diversity of TA6CM1DFW1UGNP compared with TA6GM1DFW1UGNP
Location
Part No.
Description
089G1735LAB D1
SIGNAL CABLE
A34G0093 ASB1B 30
BEZEL(20")
A34G0046 AS 3B
STAND
AM1G1740 10120
SCREW(M4*8)
750GLCA1WA713N
PANEL LCD 20.1" WA07 000 CPT
750GLCA1WA723N
PANEL LCD 20.1" WA07 011 CPT
A15G0075MT1 3
MAIN FRAME
FB401
061G0805000
0 OHM 1/10W
C425
065G0603224 32
CHIP 0.22UF 50V X7R
D426
093G 39147SEM
ZMM5V6ST
D416
093G 39147SEM
ZMM5V6ST
D415
093G 39147SEM
ZMM5V6ST
D414
093G 39147SEM
ZMM5V6ST
D412
093G 39147SEM
ZMM5V6ST
D411
093G 39147SEM
ZMM5V6ST
D410
093G 39147SEM
ZMM5V6ST
D409
093G 39147SEM
ZMM5V6ST
D408
093G 39147SEM
ZMM5V6ST
D406
093G 39147SEM
ZMM5V6ST
PWPCA62CA1P
POWER BOARD
705G 201 61 01
NR901 ASS'Y
705GQAK0 61003
R908 ASS'Y
C811
065G0603562 32
CHIP 5.6NF 50V X7R
C841
065G0603562 32
CHIP 5.6NF 50V X7R
C906
065G 2K152 1T6921
1.5NF/2KV Y5P +-10%
Q40G 20N972 1B
Rating label
Q40G0002972 1B
Box Sealing sticker
Q40G0002972 8A
ECO LABEL
Q44GA021972 1C
CARTON
Q45G 88606 R
PE BAG FOR BASE
Q45G 88606 16
R
PE BAG FOR CLAMP
Q45G 88609 10
R
EPE COVER
Q45G 88626 8
R
PE BAG FOR MONITOR
Q40G0002972 4B
LABEL
Q41G2002972 4A
manual
56
20″ LCD Color Monitor
Adelpia TGL2010A
Diversity of TA6GM1DFW1UGNC compared with TA6GM1DFW1UGNP
Location
Part No.
Description
A34G0093 ASB1B 30
BEZEL(20")
A34G0046 AS 3B
STAND
AM1G1740 10120
SCREW(M4*8)
750GLGA1W3A11N000Z
PANEL LM201WE3-TLA1 KR ADP LPL
FB401
061G0805000
0 OHM 1/10W
D406
093G 39147SEM
ZMM5V6ST
D408
093G 39147SEM
ZMM5V6ST
D409
093G 39147SEM
ZMM5V6ST
D410
093G 39147SEM
ZMM5V6ST
D411/ D412
093G 39147SEM
ZMM5V6ST
D414/ D415
093G 39147SEM
ZMM5V6ST
D416/ D426
093G 39147SEM
ZMM5V6ST
ZD109
093G 64 59 SU
ESD MLVS0603M04 0603
ZD105
093G 64 59 SU
ESD MLVS0603M04 0603
ZD104
093G 64 59 SU
ESD MLVS0603M04 0603
ZD103
093G 64 59 SU
ESD MLVS0603M04 0603
ZD107
093G 64 59 SU
ESD MLVS0603M04 0603
ZD106
093G 64 59 SU
ESD MLVS0603M04 0603
ZD108
093G 64 59 SU
ESD MLVS0603M04 0603
705G 201 61 01
NR901 ASS'Y
705GQAK0 61003
R908 ASS'Y
C821
065G060322131G
CAP CHIP 0603 220PF G 50V NPO
L901
006G 31502
1.5MM RIVET
L902
006G 31502
1.5MM RIVET
C906
065G 2K152 1T6921
1.5NF/2KV Y5P +-10%
Q40G 20N972 1B
RATING LABEL
Q40G0002972 1B
BOX SEALING STICKER
Q40G0002972 4B
LABEL
Q40G0002972 8A
ECO LABEL
Q44GA021972 1C
CARTON
Q45G 88606 R
PE BAG FOR BASE
Q45G 88606 16
R
PE BAG FOR CLAMP
Q45G 88609 10
R
EPE COVER
Q45G 88626 8
R
PE BAG FOR MONITOR
Q41G2002972 4A
MANUAL
57