Download Velleman FM3 Service manual

CDX-GT35U/GT39U/
GT39UE
SERVICE MANUAL
AEP Model
UK Model
Ver. 1.1 2010.02
CDX-GT35U/GT39U
E Model
CDX-GT35U
Russian Model
CDX-GT35U/GT39UE
Photo: CDX-GT35U
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
CDX-GT33U
CD Drive Mechanism Type
MG-101Y-188//Q
Optical Pick-up Name
DAX-25A
SPECIFICATIONS
Tuner section
FM
Tuning range:
AEP, UK, GT35U: Russian model:
87.5 – 108.0 MHz
E, Argentina model:
87.5 – 108.0 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
GT39UE:
FM1/FM2: 87.5 – 108.0 MHz (at 50 kHz step)
FM3: 65.0 – 74.0 MHz (at 30 kHz step)
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 150 kHz
Usable sensitivity: 10 dBf
Selectivity: 75 dB at 400 kHz
Signal-to-noise ratio: 70 dB (mono)
Separation: 40 dB at 1 kHz
Frequency response: 20 – 15,000 Hz
AM
E, Argentina model:
Tuning range:
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
AM tuning interval:
9 kHz/10 kHz switchable
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 25 kHz
Sensitivity: 26 μV
MW/LW
AEP, UK, Russian model:
Tuning range:
MW: 531 – 1,602 kHz
LW: 153 – 279 kHz
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 25 kHz
Sensitivity: MW: 26 μV, LW: 45μV
CD player section
Signal-to-noise ratio: 120 dB
Frequency response: 10 – 20,000 Hz
Wow and flutter: Below measurable limit
USB Player section
Interface: USB (Full-speed)
Maximum current: 500 mA
Power amplifier section
Outputs: Speaker outputs (sure seal connectors)
Speaker impedance: 4 – 8 ohms
Maximum power output:
E model: 52 W × 4 (at 4 ohms)
Except E model: 45 W × 4 (at 4 ohms)
– Continued on next page –
CDX-GT35U: E, Argentina model
FM/AM COMPACT DISC PLAYER
CDX-GT35U: AEP, UK, Russian model/GT39U/GT39UE
FM/MW/LW COMPACT DISC PLAYER
9-889-678-02
Sony Corporation
2010B04-1
© 2010.02
Audio&Video Business Group
Published by Sony Techno Create Corporation
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
General
Outputs:
Audio outputs terminal
(sub/rear switchable)
Power antenna (aerial) relay control terminal
Power amplifier control terminal
Inputs:
Telephone ATT control terminal
(AEP, UK, Russian model)
Remote controller input terminal
(AEP, UK, Russian model)
Antenna (aerial) input terminal
AUX input jack (stereo mini jack)
USB signal input connector
Tone controls:
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
Power requirements: 12 V DC car battery
(negative ground (earth))
Dimensions: Approx. 178 × 50 × 179 mm
(7 1/8 × 2 × 7 1/8 in.) (w/h/d)
Mounting dimensions:
Approx. 182 × 53 × 162 mm
(7 1/4 × 2 1/8 × 6 1/2 in.) (w/h/d)
Mass: Approx. 1.2 kg (2 lb. 11 oz.)
Supplied accessories:
Card remote commander: RM-X151 (E, Argentina model)
Parts for installation and connections (1 set)
Design and specifications are subject to change
without notice.
NOTES ON HANDLING
BLOCK OR BASE UNIT
THE OPTICAL PICK-UP
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by
the charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
TEST DISCS
Please use the following test discs for the check on the CD
section.
YEDS-18 (Part No. 3-702-101-01)
PATD-012 (Part No. 4-225-203-01)
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up
SAFETY-RELATED COMPONENT WARNING!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
semi-fixed resistor
CDX-GT35U/GT39U/GT39UE
This compact disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the exterior.
TABLE OF CONTENTS
1.
2.
SERVICE NOTE ......................................................
GENERAL
Connections ....................................................................
This label is located on the bottom of the chassis.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
4
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
Sub Panel Assy ...............................................................
CD Mechanism Block .....................................................
Main Board .....................................................................
Servo Board ....................................................................
Chassis (T) Sub Assy ......................................................
Roller Arm Assy..............................................................
Chassis (OP) Assy ...........................................................
Chucking Arm Sub Assy .................................................
Sled Motor Assy..............................................................
Optical Pick-up Section ..................................................
Optical Pick-up ...............................................................
4.
DIAGRAMS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
4-7.
4-8.
Block Diagram –Main Section– .....................................
Block Diagram –Display Section– .................................
Printed Wiring Board –Main Section–............................
Schematic Diagram –Main Section (1/3)–......................
Schematic Diagram –Main Section (2/3)–......................
Schematic Diagram –Main Section (3/3)–......................
Printed Wiring Boards –Key Section– ............................
Schematic Diagram –Key Section– ................................
5.
EXPLODED VIEWS
5
8
8
9
9
10
10
11
11
12
13
13
15
16
18
19
20
21
22
23
5-1. Main Section ................................................................... 28
5-2. Front Panel Section ......................................................... 29
5-3. CD Mechanism Section (MG-101Y-188//Q) .................. 30
6.
ELECTRICAL PARTS LIST.................................. 31
3
CDX-GT35U/GT39U/GT39UE
SECTION 1
SERVICE NOTE
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension
cable) as shown below.
•
Connect the MAIN board (CN701) and the SERVO board
(CN401) with the extension cable (Part No. J-2502-076-1).
MAIN BOARD
CN701
J-2502-076-1
SERVO BOARD
CN401
NOTE FOR REPLACEMENT OF THE USB CONNECTOR
(CN902)
To replace the USB connector requires alignment.
1. Insert the USB connector into the front panel.
2. Place the KEY board on the front panel and align the terminals
of the USB connector with the holes in the KEY board.
3. Solder the four terminals of the connector.
KEY board
USB (socket) connector
front panel
4
NOTE FOR REPLACEMENT OF THE SERVO BOARD
When repairing, the complete SERVO board (Part No.
A-1555-002-A) should be replaced since any parts in the SERVO
board cannot be repaired.
NOTE FOR THE 20-PIN CONNECTOR (CN901)
Do not use alcohol to clean the 20-pin connector (CN901) connecting the front panel with the main body.
Do not touch the connector directly with your bare hand. Poor contact may be caused.
CDX-GT35U/GT39U/GT39UE
SECTION 2
GENERAL
This section is extracted
from instruction manual.
CONNECTIONS
• E model
2#!PINCORDNOTSUPPLIED
!5$)//54CANBESWITCHED35"OR2%!2
&ORDETAILSSEETHESUPPLIED/PERATING
)NSTRUCTIONS
#ABLECONTERMINALES2#!NOSUMINISTRADO
!5$)//54SALIDADEAUDIOPUEDE
CAMBIARSEA35"O2%!20ARAOBTENER
INFORMACI˜NCONSULTEELMANUALDE
INSTRUCCIONESSUMINISTRADO
FROMCARANTENNAAERIAL
DESDELAANTENADELAUTOMØVIL
!-02%-
&USE!
&USIBLE!
"LUEWHITESTRIPED
#ONRAYASAZULESYBLANCAS

-AXSUPPLYCURRENT!
#ORRIENTEMÈXDEALIMENTACIØNDE!
7HITE
"LANCO
,EFT
)ZQUIERDO
#ONNECTIONDIAGRAM
2ED
2OJO
9ELLOW
!MARILLO
 4OTHEPOWERANTENNAAERIALCONTROLLEADOR
POWERSUPPLYLEADOFANTENNAAERIALBOOSTER
!LCABLEDECONTROLDELAANTENAMOTORIZADA
 4O!-02%-/4%).OFANOPTIONALPOWER
AMPLIlER
4HISCONNECTIONISONLYFORAMPLIlERS#ONNECTINGANYOTHER
SYSTEMMAYDAMAGETHEUNIT
 4OTHE6POWERTERMINALWHICHIS
ENERGIZEDINTHEACCESSORYPOSITIONOFTHE
IGNITIONKEYSWITCH
.OTES
s )FTHEREISNOACCESSORYPOSITIONCONNECTTOTHE6
POWERBATTERYTERMINALWHICHISENERGIZEDATALLTIMES
"ESURETOCONNECTTHEBLACKGROUNDEARTHLEADTOA
METALSURFACEOFTHECARlRST
s 7HENYOURCARHASABUILTIN&-!-ANTENNAAERIALIN
THEREARSIDEGLASSSEEh.OTESONTHECONTROLANDPOWER
SUPPLYLEADSv
 4OTHE6POWERTERMINALWHICHIS
ENERGIZEDATALLTIMES
"ESURETOCONNECTTHEBLACKGROUNDEARTHLEADTOAMETAL
SURFACEOFTHECARlRST
.OTESONTHECONTROLANDPOWERSUPPLYLEADS
s 4HEPOWERANTENNAAERIALCONTROLLEADBLUESUPPLIES6
$#WHENYOUTURNONTHETUNER
s 7HENYOURCARHASBUILTIN&-!-ANTENNAAERIALINTHEREAR
SIDEGLASSCONNECTTHEPOWERANTENNAAERIALCONTROLLEAD
BLUEORTHEACCESSORYPOWERSUPPLYLEADREDTOTHEPOWER
TERMINALOFTHEEXISTINGANTENNAAERIALBOOSTER&ORDETAILS
CONSULTYOURDEALER
s !POWERANTENNAAERIALWITHOUTARELAYBOXCANNOTBEUSED
WITHTHISUNIT
-EMORYHOLDCONNECTION
7HENTHEYELLOWPOWERINPUTLEADISCONNECTEDPOWERWILL
ALWAYSBESUPPLIEDTOTHEMEMORYCIRCUITEVENWHENTHEIGNITION
SWITCHISTURNEDOFF
.OTESONSPEAKERCONNECTION
s "EFORECONNECTINGTHESPEAKERSTURNTHEUNITOFF
s 5SESPEAKERSWITHANIMPEDANCEOFTOOHMSANDWITH
ADEQUATEPOWERHANDLINGCAPACITIESTOAVOIDITSDAMAGE
s $ONOTCONNECTTHESPEAKERTERMINALSTOTHECARCHASSISOR
CONNECTTHETERMINALSOFTHERIGHTSPEAKERSWITHTHOSEOFTHE
LEFTSPEAKER
s $ONOTCONNECTTHEGROUNDEARTHLEADOFTHISUNITTOTHE
NEGATIVEnTERMINALOFTHESPEAKER
s $ONOTATTEMPTTOCONNECTTHESPEAKERSINPARALLEL
s #ONNECTONLYPASSIVESPEAKERS#ONNECTINGACTIVESPEAKERS
WITHBUILTINAMPLIlERSTOTHESPEAKERTERMINALSMAYDAMAGE
THEUNIT
s 4OAVOIDAMALFUNCTIONDONOTUSETHEBUILTINSPEAKERLEADS
INSTALLEDINYOURCARIFTHEUNITSHARESACOMMONNEGATIVEn
LEADFORTHERIGHTANDLEFTSPEAKERS
s $ONOTCONNECTTHEUNITSSPEAKERLEADSTOEACHOTHER
.OTEONCONNECTION
)FSPEAKERANDAMPLIlERARENOTCONNECTEDCORRECTLYh&!),52%v
APPEARSINTHEDISPLAY)NTHISCASEMAKESURETHESPEAKERAND
AMPLIlERARECONNECTEDCORRECTLY
$IAGRAMADECONEXIØN
 4OAMETALSURFACEOFTHECAR
.OTES
s )TISNOTNECESSARYTOCONNECTTHISLEADIFTHEREISNOPOWER
ANTENNAAERIALORANTENNAAERIALBOOSTERORWITHA
MANUALLYOPERATEDTELESCOPICANTENNAAERIAL
s 7HENYOURCARHASABUILTIN&-!-ANTENNAAERIALIN
THEREARSIDEGLASSSEEh.OTESONTHECONTROLANDPOWER
SUPPLYLEADSv
0URPLEBLACKSTRIPED
#ONRAYASMORADASYNEGRAS
!UNASUPERlCIEMETÈLICADELAUTOMØVIL
&IRSTCONNECTTHEBLACKGROUNDEARTHLEADTHENCONNECTTHE
YELLOWANDREDPOWERSUPPLYLEADS
!.42%-AXSUPPLYCURRENT!
#ORRIENTEMÈXDEALIMENTACIØNDE!
'REENBLACKSTRIPED
#ONRAYASVERDESYNEGRAS
0URPLE
-ORADO
2IGHT
$ERECHO
"LUE
!ZUL
'RAYBLACKSTRIPED
#ONRAYASGRISESYNEGRAS
'REEN
6ERDE
,EFT
)ZQUIERDO
7HITEBLACKSTRIPED
#ONRAYASBLANCASYNEGRAS
'RAY
'RIS
2IGHT
$ERECHO
"LACK
.EGRO
#ONECTEPRIMEROELCABLEDECONEXI˜NAMASANEGROY
DESPU£SLOSCABLESAMARILLOYROJODEFUENTEDEALIMENTACI˜N
OALCABLEDEFUENTEDEALIMENTACIØNDEL
AMPLIlCADORDESE×ALDELAANTENA
.OTAS
s 3INOSEDISPONEDEANTENAMOTORIZADANIDEAMPLIlCADOR
DEANTENAOSEUTILIZAUNAANTENATELESC˜PICAACCIONADA
MANUALMENTENOSERÕNECESARIOCONECTARESTECABLE
s 3IELAUTOM˜VILINCORPORAUNAANTENADE&-!-ENEL
CRISTALTRASEROOLATERALCONSULTEh.OTASSOBRELOSCABLES
DECONTROLYDEFUENTEDEALIMENTACI˜Nv
!!-02%-/4%).DEUNAMPLIlCADORDE
POTENCIAOPCIONAL
%STACONEXI˜NESS˜LOPARAAMPLIlCADORES,ACONEXI˜NDE
CUALQUIEROTROSISTEMAPUEDEDA¶ARLAUNIDAD
 !LTERMINALDEALIMENTACIØNDE6QUE
RECIBEENERGÓAENLAPOSICIØNDEACCESORIO
DELINTERRUPTORDEENCENDIDO
.OTAS
s 3INOHAYPOSICI˜NDEACCESORIOCON£CTELOALTERMINALDE
ALIMENTACI˜NBATER¤ADE6QUERECIBEENERG¤ASIN
INTERRUPCI˜N
!SEG¢RESEDECONECTARPRIMEROELCABLEDECONEXI˜NA
MASANEGROAUNASUPERlCIEMETÕLICADELAUTOM˜VIL
s 3IELAUTOM˜VILINCORPORAUNAANTENADE&-!-ENEL
CRISTALTRASEROOLATERALCONSULTEh.OTASSOBRELOSCABLES
DECONTROLYDEFUENTEDEALIMENTACI˜Nv
 !LTERMINALDEALIMENTACIØNDE6QUE
RECIBEENERGÓASININTERRUPCIØN
!SEG¢RESEDECONECTARPRIMEROELCABLEDECONEXI˜NAMASA
NEGROAUNASUPERlCIEMETÕLICADELAUTOM˜VIL
.OTASSOBRELOSCABLESDECONTROLYDEFUENTEDE
ALIMENTACIØN
s %LCABLEDECONTROLDELAANTENAMOTORIZADAAZULSUMINISTRARÕ
CCDE6CUANDOCONECTELAALIMENTACI˜NDELSINTONIZADOR
s 3IELAUTOM˜VILDISPONEDEUNAANTENADE&-!-INCORPORADA
ENELCRISTALTRASEROOLATERALCONECTEELCABLEDECONTROLDE
ANTENAMOTORIZADAAZULOELCABLEDEFUENTEDEALIMENTACI˜N
AUXILIARROJOALTERMINALDEALIMENTACI˜NDELAMPLIlCADORDE
ANTENAEXISTENTE0ARAOBTENERMÕSINFORMACI˜NCONSULTEASU
DISTRIBUIDOR
s #ONESTAUNIDADNOESPOSIBLEUTILIZARUNAANTENAMOTORIZADA
SINCAJADEREL£
#ONEXIØNPARAPROTECCIØNDELAMEMORIA
3ICONECTAELCABLEDEFUENTEDEALIMENTACI˜NAMARILLOELCIRCUITO
DELAMEMORIARECIBIRÕSIEMPREALIMENTACI˜NAUNQUEAPAGUEEL
INTERRUPTORDEENCENDIDO
.OTASSOBRELACONEXIØNDELOSALTAVOCES
s !NTESDECONECTARLOSALTAVOCESDESCONECTELAALIMENTACI˜N
DELAUNIDAD
s 5TILICEALTAVOCESCONUNAIMPEDANCIADEAΩCONLA
CAPACIDADDEPOTENCIAADECUADAPARAEVITARQUESEDA¶EN
s .OCONECTELOSTERMINALESDEALTAVOZALCHASISDELAUTOM˜VIL
NICONECTELOSTERMINALESDELALTAVOZDERECHOCONLOSDEL
IZQUIERDO
s .OCONECTEELCABLEDECONEXI˜NAMASADEESTAUNIDADAL
TERMINALNEGATIVOnDELALTAVOZ
s .OINTENTECONECTARLOSALTAVOCESENPARALELO
s #ONECTESOLAMENTEALTAVOCESPASIVOS3ICONECTAALTAVOCES
ACTIVOSCONAMPLIlCADORESINCORPORADOSALOSTERMINALESDE
ALTAVOZPUEDEDA¶ARLAUNIDAD
s 0ARAEVITARFALLASDEFUNCIONAMIENTONOUTILICELOSCABLESDE
ALTAVOZINCORPORADOSINSTALADOSENELAUTOM˜VILSILAUNIDAD
COMPARTEUNCABLENEGATIVOCOM¢NnPARALOSALTAVOCES
DERECHOEIZQUIERDO
s .OCONECTELOSCABLESDEALTAVOZDELAUNIDADENTRES¤
.OTASOBRELACONEXIØN
3IELALTAVOZYELAMPLIlCADORNOESTÕNCONECTADOS
CORRECTAMENTEAPARECERÕh&!),52%vENLAPANTALLA3IESAS¤
COMPRUEBELACONEXI˜NDEAMBOSDISPOSITIVOS
5
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
• AEP, UK, Russian, Argentina model
(INWEISZUM!NSCHLIE”ENDER!NTENNE
.OTEFORTHEANTENNAAERIALCONNECTING
)FYOURCARANTENNAAERIALISAN
7ENN)HRE!UTOANTENNEDER)3/.ORM
)3/)NTERNATIONAL/RGANIZATIONFOR
)NTERNATIONALE.ORMUNGSGEMEINSCHAFT
3TANDARDIZATIONTYPEUSETHESUPPLIED
ENTSPRICHTSCHLIE”EN3IESIEMITHILFEDES
ADAPTORTOCONNECTIT&IRSTCONNECTTHECAR
MITGELIEFERTEN!DAPTERSAN6ERBINDEN
ANTENNAAERIALTOTHESUPPLIEDADAPTORTHEN
3IEZUERSTDIE!UTOANTENNEMITDEM
CONNECTITTOTHEANTENNAAERIALJACKOFTHE
MITGELIEFERTEN!DAPTERUNDVERBINDEN3IE
MASTERUNIT
DIESENDANNMITDER!NTENNENBUCHSEDES
2#!PINCORDNOTSUPPLIED
(AUPTGERØTS
!5$)//54CANBESWITCHED35"OR2%!2 #INCHKABELNICHTMITGELIEFERT
&ORDETAILSSEETHESUPPLIED/PERATING
!5$)//54KANNZWISCHEN35"UND
)NSTRUCTIONS
2%!2UMGESCHALTETWERDEN.ØHERES
3EPARATEADAPTORMAYBEREQUIRED
HIERZUlNDEN3IEINDERMITGELIEFERTEN
"EDIENUNGSANLEITUNG
-šGLICHERWEISEISTEINSEPARATER!DAPTER
ERFORDERLICH

FROMCARANTENNAAERIAL
VON!UTOANTENNE
DELANTENNEDELAVOITURE
DALLANTENNADELLAUTO
VANEENAUTOANTENNE
2EMARQUESURLERACCORDEMENTDELANTENNE
3IVOTREANTENNEDEVOITUREESTDETYPE
)3//RGANISATIONINTERNATIONALEDE
NORMALISATIONUTILISEZLADAPTATEURFOURNI
POURLARACCORDER2ACCORDEZDABORD
LANTENNEDEVOITUREÍLADAPTATEURFOURNIET
ENSUITEÍLAPRISEDANTENNEDELAPPAREIL
PRINCIPAL
#ORDONÍBROCHE2#!NONFOURNI
!5$)//54PEUTãTRECOMMUT£SUR35"OU
2%!20OUROBTENIRPLUSDED£TAILSREPORTEZ
VOUSAUMODEDEMPLOI
5NADAPTATEURS£PAR£PEUTãTREN£CESSAIRE
/PMERKINGBIJDEANTENNEAANSLUITING
)NDIENUWAUTOISUITGERUSTMETEENANTENNE
VANHETTYPE)3/)NTERNATIONAL/RGANIZATION
FOR3TANDARDIZATIONMOETUDIEAANSLUITEN
METBEHULPVANDEBIJGELEVERDEADAPTER
3LUITEERSTDEAUTOANTENNEAANOP
DEBIJGELEVERDEADAPTERENVERVOLGENSDE
ANTENNESTEKKEROPHETHOOFDTOESTEL
4ULPSTEKKERSNOERNIETBIJGELEVERD
!5$)//54KANWORDENINGESTELDOP35"
OF2%!22AADPLEEGDEGEBRUIKSAANWIJZING
VOORMEERINFORMATIE
%RISMOGELIJKEENAFZONDERLIJKEADAPTER
VEREIST
-AXSUPPLYCURRENT!
MAX6ERSORGUNGSSTROM!
#OURANTDALIMENTATIONMAXIMUM!
!LIMENTAZIONEMASSIMAFORNITA!
-AXVOEDINGSSTROOM!
!-02%-
&USE!
3ICHERUNG!
&USIBLE!
&USIBILE!
:EKERING!
"LUEWHITESTRIPED
"LAUWEI”GESTREIFT
2AYÏBLEUBLANC
2IGATOBLUEBIANCO
"LAUWWITGESTREEPT
!44

,IGHTBLUE
(ELLBLAU
"LEUCIEL
!ZZURRO
,ICHTBLAUW
3EEh0OWERCONNECTIONDIAGRAMvONTHEREVERSESIDEFORDETAILS
6OIRLEi3CHÏMADERACCORDEMENTDALIMENTATIONwAUVERSOPOUR
PLUSDEDÏTAILS
0ERULTERIORIINFORMAZIONIVEDEREh$IAGRAMMADEICOLLEGAMENTIDI
ALIMENTAZIONEvCHESITROVASULRETRO
:IE6OEDINGSAANSLUITSCHEMAOPDEACHTERKANTVOORMEERDETAILS
9ELLOW
'ELB
*AUNE
'IALLO
'EEL
CONTINUOUSPOWERSUPPLY
PERMANENTE3TROMVERSORGUNG
ALIMENTATIONCONTINUE
ALIMENTAZIONECONTINUA
CONTINUVOEDING
"LUE
"LAU
"LEU
"LU
"LAUW
POWERANTENNAAERIALCONTROL
-OTORANTENNENSTEUERUNG
ANTENNEÏLECTRIQUE
COMANDODELLANTENNAELETTRICA
ELEKTRISCHEANTENNE
#ONNECTIONDIAGRAM
4HISCONNECTIONISONLYFORAMPLIlERS#ONNECTINGANYOTHER
SYSTEMMAYDAMAGETHEUNIT
 4OTHEINTERFACECABLEOFACARTELEPHONE
7ARNING
)FYOUHAVEAPOWERANTENNAAERIALWITHOUTARELAYBOX
CONNECTINGTHISUNITWITHTHESUPPLIEDPOWERSUPPLYLEAD
MAYDAMAGETHEANTENNAAERIAL
.OTESONTHECONTROLANDPOWERSUPPLYLEADS
s 4HEPOWERANTENNAAERIALCONTROLLEADBLUESUPPLIES6
$#WHENYOUTURNONTHETUNERORWHENYOUACTIVATETHE!&
!LTERNATIVE&REQUENCYOR4!4RAFlC!NNOUNCEMENTFUNCTION
s 7HENYOURCARHASBUILTIN&--7,7ANTENNAAERIALINTHE
REARSIDEGLASSCONNECTTHEPOWERANTENNAAERIALCONTROL
LEADBLUEORTHEACCESSORYPOWERSUPPLYLEADREDTOTHE
POWERTERMINALOFTHEEXISTINGANTENNAAERIALBOOSTER&OR
DETAILSCONSULTYOURDEALER
s !POWERANTENNAAERIALWITHOUTARELAYBOXCANNOTBEUSED
WITHTHISUNIT
-EMORYHOLDCONNECTION
7HENTHEYELLOWPOWERSUPPLYLEADISCONNECTEDPOWERWILL
ALWAYSBESUPPLIEDTOTHEMEMORYCIRCUITEVENWHENTHEIGNITION
SWITCHISTURNEDOFF
.OTESONSPEAKERCONNECTION
s "EFORECONNECTINGTHESPEAKERSTURNTHEUNITOFF
s 5SESPEAKERSWITHANIMPEDANCEOFTOOHMSANDWITH
ADEQUATEPOWERHANDLINGCAPACITIESTOAVOIDITSDAMAGE
s $ONOTCONNECTTHESPEAKERTERMINALSTOTHECARCHASSISOR
CONNECTTHETERMINALSOFTHERIGHTSPEAKERSWITHTHOSEOFTHE
LEFTSPEAKER
s $ONOTCONNECTTHEGROUNDEARTHLEADOFTHISUNITTOTHE
NEGATIVEnTERMINALOFTHESPEAKER
s $ONOTATTEMPTTOCONNECTTHESPEAKERSINPARALLEL
s #ONNECTONLYPASSIVESPEAKERS#ONNECTINGACTIVESPEAKERS
WITHBUILTINAMPLIlERSTOTHESPEAKERTERMINALSMAYDAMAGE
THEUNIT
s 4OAVOIDAMALFUNCTIONDONOTUSETHEBUILTINSPEAKERLEADS
INSTALLEDINYOURCARIFTHEUNITSHARESACOMMONNEGATIVEn
LEADFORTHERIGHTANDLEFTSPEAKERS
s $ONOTCONNECTTHEUNITSSPEAKERLEADSTOEACHOTHER
.OTEONCONNECTION
)FSPEAKERANDAMPLIlERARENOTCONNECTEDCORRECTLYh&!),52%v
APPEARSINTHEDISPLAY)NTHISCASEMAKESURETHESPEAKERAND
AMPLIlERARECONNECTEDCORRECTLY
!NSCHLUSSDIAGRAMM
SWITCHEDPOWERSUPPLY
GESCHALTETE3TROMVERSORGUNG
ALIMENTATIONCOMMUTÏE
ALIMENTAZIONECOMMUTATA
GESCHAKELDEVOEDING
"LACK
3CHWARZ
.OIR
.ERO
:WART
GROUNDEARTH
-ASSE
MASSE
TERRA
AARDING
3CHÏMASDERACCORDEMENT
 !N!-02%-/4%).DESGESONDERT
ERHÊLTLICHEN%NDVERSTÊRKERS
 !UNIVEAUDU!-02%-/4%).DUN
AMPLIlCATEURDEPUISSANCEFACULTATIF
 !N3CHNITTSTELLENKABELEINES!UTOTELEFONS
 6ERSLECORDONDELIAISONDUNTÏLÏPHONEDE
VOITURE
$IESER!NSCHLUSSISTAUSSCHLIE”LICHFÓR6ERSTØRKERGEDACHT
3CHLIE”EN3IENICHTSANDERESDARANAN!NDERNFALLSKANN
DAS'ERØTBESCHØDIGTWERDEN
7ARNUNG
7ENN3IEEINE-OTORANTENNEOHNE2ELAISKØSTCHEN
VERWENDENKANNDURCH!NSCHLIE”ENDIESES'ERØTSMIT
DEMMITGELIEFERTEN3TROMVERSORGUNGSKABELDIE
!NTENNEBESCHØDIGTWERDEN
(INWEISEZUDEN3TEUERUND3TROMVERSORGUNGSLEITUNGEN
s $IE-OTORANTENNEN3TEUERLEITUNGBLAULIEFERT6
'LEICHSTROMWENN3IEDEN4UNEREINSCHALTENODERDIE
!&!LTERNATIVFREQUENZSUCHEODERDIE4!&UNKTION
6ERKEHRSDURCHSAGENAKTIVIEREN
s 7ENNDAS&AHRZEUGMITEINERINDER(ECK
3EITENFENSTERSCHEIBEINTEGRIERTEN&-5+7-7,7
!NTENNEAUSGESTATTETISTSCHLIE”EN3IEDIE-OTORANTENNEN
3TEUERLEITUNGBLAUODERDIE:UBEHšRSTROMVERSORGUNGSLEITUNG
ROTANDEN3TROMVERSORGUNGSANSCHLUSSDESVORHANDENEN
!NTENNENVERSTØRKERSAN.ØHERESDAZUERFAHREN3IEBEI)HREM
(ØNDLER
s %SKANNNUREINE-OTORANTENNEMIT2ELAISKØSTCHEN
ANGESCHLOSSENWERDEN
#ERACCORDEMENTEXISTESEULEMENTPOURLESAMPLIlCATEURS
,ERACCORDEMENTÍTOUTAUTRESYSTÞMEPEUTENDOMMAGER
LAPPAREIL
!VERTISSEMENT
3IVOUSDISPOSEZDUNEANTENNE£LECTRIQUESANSBO¦TIER
DERELAISLEBRANCHEMENTDECETAPPAREILAUMOYENDU
CORDONDALIMENTATIONFOURNIRISQUEDENDOMMAGER
LANTENNE
2EMARQUESSURLESCÉBLESDECOMMANDEETDALIMENTATION
s ,ECºBLEDECOMMANDEDANTENNE£LECTRIQUEBLEUFOURNITDU
COURANTCONTINUDE6LORSQUEVOUSMETTEZLETUNERSOUS
TENSIONOULORSQUEVOUSACTIVEZLAFONCTION!&FR£QUENCE
ALTERNATIVEOU4!INFORMATIONSDECIRCULATION
s ,ORSQUEVOTREVOITUREEST£QUIP£EDUNEANTENNE&--7
'/,70/INT£GR£EDANSLAVITREARRIÞRELAT£RALERACCORDEZ
LECºBLEDECOMMANDEDANTENNE£LECTRIQUEBLEUOULE
CºBLEDALIMENTATIONDESACCESSOIRESROUGEAUBORNIER
DELAMPLIlCATEURDANTENNEEXISTANT0OURPLUSDED£TAILS
CONSULTEZVOTREREVENDEUR
s 5NEANTENNE£LECTRIQUESANSBO¦TIERDERELAISNEPEUTPASãTRE
UTILIS£EAVECCETAPPAREIL
3TROMVERSORGUNGDES3PEICHERS
7ENNDIEGELBE3TROMVERSORGUNGSLEITUNGANGESCHLOSSENIST
WIRDDER3PEICHERSTETSAUCHBEIAUSGESCHALTETER:ÓNDUNGMIT
3TROMVERSORGT
2ACCORDEMENTPOURLACONSERVATIONDELAMÏMOIRE
,ORSQUELECºBLEDALIMENTATIONJAUNEESTRACCORD£LECIRCUIT
DELAM£MOIREESTALIMENT£ENPERMANENCEMãMESILACL£DE
CONTACTESTENPOSITIONDARRãT
(INWEISEZUM,AUTSPRECHERANSCHLUSS
s 3CHALTEN3IEDAS'ERØTAUSBEVOR3IEDIE,AUTSPRECHER
ANSCHLIE”EN
s 6ERWENDEN3IE,AUTSPRECHERMITEINER)MPEDANZZWISCHENUND
/HMUNDAUSREICHENDER"ELASTBARKEIT!NSONSTENKšNNENDIE
,AUTSPRECHERBESCHØDIGTWERDEN
s6ERBINDEN3IEDIE,AUTSPRECHERANSCHLÓSSENICHTMITDEM
7AGENCHASSISUNDVERBINDEN3IEAUCHNICHTDIE!NSCHLÓSSE
DESRECHTENMITDENENDESLINKEN,AUTSPRECHERS
s 6ERBINDEN3IEDIE-ASSELEITUNGDIESES'ERØTSNICHTMITDEM
NEGATIVENn,AUTSPRECHERANSCHLUSS
s 6ERSUCHEN3IENICHT,AUTSPRECHERPARALLELANZUSCHLIE”EN
s !NDIE,AUTSPRECHERANSCHLÓSSEDIESES'ERØTSDÓRFENNUR
0ASSIVLAUTSPRECHERANGESCHLOSSENWERDEN3CHLIE”EN3IE
KEINE!KTIVLAUTSPRECHER,AUTSPRECHERMITEINGEBAUTEN
6ERSTØRKERNANDADAS'ERØTSONSTBESCHØDIGTWERDEN
KšNNTE
s 5M&EHLFUNKTIONENZUVERMEIDENVERWENDEN3IENICHTDIE
IM&AHRZEUGINSTALLIERTENINTEGRIERTEN,AUTSPRECHERLEITUNGEN
WENNAM%NDEEINEGEMEINSAMENEGATIVEn,EITUNGFÓRDEN
RECHTENUNDDENLINKEN,AUTSPRECHERVERWENDETWIRD
s 6ERBINDEN3IENICHTDIE,AUTSPRECHERKABELDES'ERØTS
MITEINANDER
2EMARQUESSURLERACCORDEMENTDESHAUTPARLEURS
s !VANTDERACCORDERLESHAUTPARLEURSMETTRELAPPAREILHORS
TENSION
s 5TILISERDESHAUTPARLEURSAYANTUNEIMP£DANCEDEÍOHMS
ETUNECAPACIT£AD£QUATESOUSPEINEDELESENDOMMAGER
s .EPASRACCORDERLESBORNESDUSYSTÞMEDEHAUTPARLEURSAU
CHºSSISDELAVOITUREETNEPASCONNECTERLESBORNESDUHAUT
PARLEURDROITÍCELLESDUHAUTPARLEURGAUCHE
s .EPASRACCORDERLECºBLEDEMISEÍLAMASSEDECETAPPAREIL
ÍLABORNEN£GATIVEnDUHAUTPARLEUR
s .EPASTENTERDERACCORDERLESHAUTPARLEURSENPARALLÞLE
s #ONNECTERUNIQUEMENTDESHAUTPARLEURSPASSIFS,A
CONNEXIONDEHAUTPARLEURSACTIFSAVECDESAMPLIlCATEURS
INT£GR£SAUXBORNESDESHAUTPARLEURSPOURRAITENDOMMAGER
LAPPAREIL
s 0OUR£VITERTOUTPROBLÞMEDEFONCTIONNEMENTNUTILISEZPASLES
CºBLESDESHAUTPARLEURSINT£GR£SINSTALL£SDANSVOTREVOITURE
SILAPPAREILDISPOSEDUNCºBLEN£GATIFCOMMUNnPOURLES
HAUTPARLEURSDROITETGAUCHE
s .ERACCORDEZPASENTREEUXLESCORDONSDESHAUTPARLEURSDE
LAPPAREIL
(INWEISZUM!NSCHLIE”EN
7ENN,AUTSPRECHERUND6ERSTØRKERNICHTRICHTIGANGESCHLOSSEN
SINDERSCHEINTu&!),52%hIM$ISPLAY6ERGEWISSERN3IESICH
INDIESEM&ALLDASS,AUTSPRECHERUND6ERSTØRKERRICHTIG
ANGESCHLOSSENSIND
2ED
2OT
2OUGE
2OSSO
2OOD
2EMARQUESURLERACCORDEMENT
3ILESENCEINTESETLAMPLIlCATEURNESONTPASRACCORD£S
CORRECTEMENTLEMESSAGEi&!),52%wSAFlCHE$ANSCECAS
ASSUREZVOUSQUELESENCEINTESETLAMPLIlCATEURSONTRACCORD£S
CORRECTEMENT
3PEAKER2EAR2IGHT
,AUTSPRECHERHINTENRECHTS
(AUTPARLEURARRIÒREDROIT
$IFFUSOREPOSTERIOREDESTRO
,UIDSPREKERACHTERRECHTS
0URPLE
6IOLETT
6IOLET
6IOLA
0AARS
n
3PEAKER2EAR2IGHT
,AUTSPRECHERHINTENRECHTS
(AUTPARLEURARRIÒREDROIT
$IFFUSOREPOSTERIOREDESTRO
,UIDSPREKERACHTERRECHTS
'RAY
'RAU
'RIS
'RIGIO
'RIJS
3PEAKER&RONT2IGHT
,AUTSPRECHERVORNERECHTS
(AUTPARLEURAVANTDROIT
$IFFUSOREANTERIOREDESTRO
,UIDSPREKERVOORRECHTS
n
3PEAKER&RONT2IGHT
,AUTSPRECHERVORNERECHTS
(AUTPARLEURAVANTDROIT
$IFFUSOREANTERIOREDESTRO
,UIDSPREKERVOORRECHTS
7HITE
7EI”
"LANC
"IANCO
7IT
'REEN
'RàN
6ERT
6ERDE
'ROEN
3PEAKER&RONT,EFT
,AUTSPRECHERVORNELINKS
(AUTPARLEURAVANTGAUCHE
$IFFUSOREANTERIORESINISTRO
,UIDSPREKERVOORLINKS
n
3PEAKER&RONT,EFT
,AUTSPRECHERVORNELINKS
(AUTPARLEURAVANTGAUCHE
$IFFUSOREANTERIORESINISTRO
,UIDSPREKERVOORLINKS
3PEAKER2EAR,EFT
,AUTSPRECHERHINTENLINKS
(AUTPARLEURARRIÒREGAUCHE
$IFFUSOREPOSTERIORESINISTRO
,UIDSPREKERACHTERLINKS
n
3PEAKER2EAR,EFT
,AUTSPRECHERHINTENLINKS
(AUTPARLEURARRIÒREGAUCHE
$IFFUSOREPOSTERIORESINISTRO
,UIDSPREKERACHTERLINKS
.EGATIVEPOLARITYPOSITIONSANDHAVESTRIPEDLEADS
!NDENNEGATIVGEPOLTEN0OSITIONENUNDBElNDENSICHGESTREIFTE!DERN
,ESPOSITIONSDEPOLARIT£N£GATIVEETSONTDOT£ESDECORDONSRAY£S
,EPOSIZIONIAPOLARITÍNEGATIVAEHANNOCAVIRIGATI
$EPOSITIESVOORNEGATIEVEPOLARITEITENHEBBENGESTREEPTEKABELS
0OSITIONSANDDONOTHAVEPINS
!N0OSITIONUNDBElNDENSICHKEINE3TIFTE
,ESPOSITIONSETNECOMPORTENTPASDEBROCHES
,EPOSIZIONIENONHANNOPIEDINI
$EPOSITIESENHEBBENGEENPINS
 4O!-02%-/4%).OFANOPTIONALPOWER
AMPLIlER
FROMTHECARSPOWERCONNECTOR
VOM3TROMANSCHLUSSDES&AHRZEUGS
DUCONNECTEURDALIMENTATIONDELAVOITURE
DALCONNETTOREDIALIMENTAZIONEDELLAUTO
VANDEAUTOVOEDINGSAANSLUITING
.ÊHERESDAZUlNDEN3IEIMu3TROMANSCHLUSSDIAGRAMMh"LÊTTERN
3IEDAZUBITTEUM
FROMTHECARSSPEAKERCONNECTOR
VOM,AUTSPRECHERANSCHLUSSDES&AHRZEUGS
DUCONNECTEURDEHAUTPARLEURDELAVOITURE
DALCONNETTOREDEIDIFFUSORIDELLAUTO
VANDEAUTOLUIDSPREKERAANSLUITING
6
.OTAPERILCOLLEGAMENTODELLANTENNA
3ELANTENNADELLAUTOÞDITIPO
)3/)NTERNATIONAL/RGANIZATIONFOR
3TANDARDIZATIONUTILIZZARELADATTATORE
INDOTAZIONEPERCOLLEGARLA#OLLEGAREPRIMA
LANTENNADELLAMACCHINAALLADATTATORE
INDOTAZIONEQUINDICOLLEGARLAALLAPRESA
DELLANTENNADELLAPPARECCHIOPRINCIPALE
#AVOAPIEDINI2#!NONINDOTAZIONE
!5$)//54PUÏESSEREIMPOSTATOSU
35"OSU2%!20ERULTERIORIINFORMAZIONI
CONSULTAREILMANUALEDIISTRUZIONIPERLUSO
0OTREBBEESSERENECESSARIOUNADATTATORE
SEPARATO
3CHEMADICOLLEGAMENTO
!ANSLUITSCHEMA
 !!-02%-/4%).DIUNAMPLIlCATOREDI
POTENZAOPZIONALE
 .AAR!-02%-/4%).VANEENOPTIONELE
EINDVERSTERKER
 !LCAVODIINTERFACCIADIUNTELEFONOPERAUTO
 .AARHETINTERFACESNOERVANEEN
AUTOTELEFOON
1UESTOCOLLEGAMENTOÞRISERVATOESCLUSIVAMENTEAGLI
AMPLIlCATORI.ONCOLLEGAREUNTIPODISISTEMADIVERSOONDE
EVITAREDICAUSAREDANNIALLAPPARECCHIO
!VVERTENZA
1UANDOSICOLLEGALAPPARECCHIOCONILCAVODI
ALIMENTAZIONEINDOTAZIONESIPOTREBBEDANNEGGIARE
LANTENNAELETTRICASEQUESTANONDISPONEDISCATOLAARELÞ
.OTESUICAVIDICONTROLLOEDIALIMENTAZIONE
s )LCAVOBLUDICONTROLLODELLANTENNAELETTRICAFORNISCE
ALIMENTAZIONEPARIA6##QUANDOSIATTIVAIL
SINTONIZZATOREOPPURELAFUNZIONE4!NOTIZIARIOSULTRAFlCOO
!&FREQUENZAALTERNATIVA
s 3ELAUTOMOBILEÞDOTATADIANTENNA&--7,7INCORPORATA
NELVETROPOSTERIORELATERALECOLLEGAREILCAVOBLUDI
CONTROLLODELLANTENNAELETTRICAOILCAVOROSSODIINGRESSO
DELLALIMENTAZIONEACCESSORIAALTERMINALEDIALIMENTAZIONE
DELPREAMPLIlCATOREDELLANTENNAESISTENTE0ERULTERIORI
INFORMAZIONICONSULTAREILPROPRIOFORNITORE
s .ONÞPOSSIBILEUSAREUNANTENNAELETTRICASENZASCATOLAARELÞ
CONQUESTOAPPARECCHIO
$EZEAANSLUITINGISALLEENBEDOELDVOORVERSTERKERS$OOR
EENANDERSYSTEEMAANTESLUITENKANHETAPPARAATWORDEN
BESCHADIGD
7AARSCHUWING
)NDIENUEENELEKTRISCHEANTENNEHEBTZONDERRELAISKAST
KANHETAANSLUITENVANDITAPPARAATMETDEBIJGELEVERDE
VOEDINGSKABELDEANTENNEBESCHADIGEN
/PMERKINGENOVERDEBEDIENINGSENVOEDINGSKABELS
s $EBEDIENINGSKABELVOORDEELEKTRISCHEANTENNEBLAUWLEVERT
6GELIJKSTROOMWANNEERUDETUNERINSCHAKELTOFDE!&
!LTERNATIVE&REQUENCYOF4!4RAFlC!NNOUNCEMENTFUNCTIE
ACTIVEERT
s 7ANNEERUWAUTOISUITGERUSTMETEEN&--7,7ANTENNE
INDEACHTERRUITZIJRUITMOETUDEBEDIENINGSKABELVOOR
DEELEKTRISCHEANTENNEBLAUWOFDEHULPVOEDINGSKABEL
ROODAANSLUITENOPDEVOEDINGSINGANGVANDEBESTAANDE
ANTENNEVERSTERKER2AADPLEEGUWDEALERVOORMEERDETAILS
s -ETDITAPPARAATISHETNIETMOGELIJKEENELEKTRISCHEANTENNE
ZONDERRELAISKASTTEGEBRUIKEN
#OLLEGAMENTOPERLACONSERVAZIONEDELLAMEMORIA
1UANDOILCAVODIINGRESSOALIMENTAZIONEGIALLOÞCOLLEGATO
VIENESEMPREFORNITAALIMENTAZIONEALCIRCUITODIMEMORIAANCHE
QUANDOLINTERRUTTOREDIACCENSIONEÞSPENTO
)NSTANDHOUDENVANHETGEHEUGEN
:OLANGDEGELEVOEDINGSKABELISAANGESLOTENBLIJFTDE
STROOMVOORZIENINGVANHETGEHEUGENINTACTOOKWANNEERHET
CONTACTVANDEAUTOWORDTUITGESCHAKELD
.OTESULCOLLEGAMENTODEIDIFFUSORI
s 0RIMADICOLLEGAREIDIFFUSORISPEGNERELAPPARECCHIO
s 5SAREDIFFUSORIDIIMPEDENZACOMPRESATRAEOHMECON
CAPACITÍDIPOTENZAADEGUATAALTRIMENTIIDIFFUSORIPOTREBBERO
VENIREDANNEGGIATI
s .ONCOLLEGAREITERMINALIDELSISTEMADIFFUSORIALTELAIODELLAUTO
ENONCOLLEGAREITERMINALIDELDIFFUSOREDESTROAQUELLIDEL
DIFFUSORESINISTRO
s .ONCOLLEGAREILCAVODITERRADIQUESTOAPPARECCHIOAL
TERMINALENEGATIVOnDELDIFFUSORE
s .ONCOLLEGAREIDIFFUSORIINPARALLELO
s !SSICURARSIDICOLLEGARESOLTANTODIFFUSORIPASSIVIPOICH£
ILCOLLEGAMENTODIDIFFUSORIATTIVIDOTATIDIAMPLIlCATORI
INCORPORATIAITERMINALIDEIDIFFUSORIPOTREBBEDANNEGGIARE
LAPPARECCHIO
s 0EREVITAREPROBLEMIDIFUNZIONAMENTONONUTILIZZAREICAVIDEI
DIFFUSORIINCORPORATIINSTALLATINELLAUTOMOBILESELAPPARECCHIO
CONDIVIDEUNCAVOCOMUNENEGATIVOnPERIDIFFUSORIDESTROE
SINISTRO
s .ONCOLLEGAREFRALOROICAVIDEIDIFFUSORIDELLAPPARECCHIO
/PMERKINGENBETREFFENDEHETAANSLUITENVANDELUIDSPREKERS
s :ORGDATHETAPPARAATISUITGESCHAKELDALVORENSDE
LUIDSPREKERSAANTESLUITEN
s 'EBRUIKLUIDSPREKERSMETEENIMPEDANTIEVANTOT/HM
ENLETOPDATDIEHETVERMOGENVANDEVERSTERKERKUNNEN
VERWERKEN!LSUDITNIETDOETKUNNENDELUIDSPREKERSERNSTIG
BESCHADIGDRAKEN
s 6ERBINDINGEENGEVALDEAANSLUITINGENVANDELUIDSPREKERS
METHETCHASSISVANDEAUTOENSLUITDEAANSLUITINGENVANDE
RECHTERENLINKERLUIDSPREKERNIETOPELKAARAAN
s 6ERBINDDEAARDDRAADVANDITAPPARAATNIETMETDENEGATIEVE
nAANSLUITINGVANDELUIDSPREKER
s 0ROBEERNOOITDELUIDSPREKERSPARALLELAANTESLUITEN
s 3LUITGEENACTIEVELUIDSPREKERSMETINGEBOUWDEVERSTERKERS
AANOPDELUIDSPREKERAANSLUITINGVANDITAPPARAAT$ITZAL
LEIDENTOTBESCHADIGINGVANDEACTIEVELUIDSPREKERS3LUITDUS
ALTIJDUITSLUITENDLUIDSPREKERSZONDERINGEBOUWDEVERSTERKER
AAN
s /MDEFECTENTEVERMIJDENMAGUDEBESTAANDE
LUIDSPREKERBEDRADINGINUWAUTONIETGEBRUIKENWANNEEREREEN
GEMEENSCHAPPELIJKENEGATIEVEnDRAADISVOORDERECHTEREN
LINKERLUIDSPREKERS
s 6ERBINDDELUIDSPREKERDRADENNIETMETELKAAR
.OTASUICOLLEGAMENTI
3ELAMPLIlCATOREEILDIFFUSORENONSONOCOLLEGATICORRETTAMENTE
h&!),52%vVIENEVISUALIZZATONELDISPLAY)NTALCASOACCERTARSI
CHELAMPLIlCATOREEILDIFFUSORESIANOCOLLEGATICORRETTAMENTE
/PMERKINGOVERAANSLUITEN
!LSDELUIDSPREKERENVERSTERKERNIETCORRECTZIJNAANGESLOTEN
WORDT&!),52%INHETDISPLAYWEERGEGEVEN)NDITGEVALMOETU
ZORGENDATDELUIDSPREKERENVERSTERKERCORRECTZIJNAANGESLOTEN
CDX-GT35U/GT39U/GT39UE
SECTION 3
DISASSEMBLY
•
This set can be disassembled in the order shown below.
SET
3-1.
SUB PANEL ASSY
(Page 8)
3-2.
CD MECHANISM BLOCK
(Page 8)
3-3.
MAIN BOARD
(Page 9)
3-4.
SERVO BOARD
(Page 9)
3-5.
CHASSIS (T) SUB ASSY
(Page 10)
3-6.
ROLLER ARM ASSY
(Page 10)
3-7.
CHASSIS (OP) ASSY
(Page 11)
3-8.
CHUCKING ARM SUB ASSY
(Page 11)
3-9.
SLED MOTOR ASSY
(Page 12)
3-10.
OPTICAL PICK-UP SECTION
(Page 13)
3-11.
OPTICAL PICK-UP
(Page 13)
7
CDX-GT35U/GT39U/GT39UE
Note: Follow the disassembly procedure in the numerical order shown below.
3-1.
SUB PANEL ASSY
two claws
two claws
two screws
(+PTT 2.6 × 6)
sub panel assy
3-2.
CD MECHANISM BLOCK
8 CD mechanism block
7 bracket (CD)
6 two screws
(+PTT 2.6 u 4)
2 screw
(+PTT 2.6 u 6)
3
5 CN501 (3P)
4 CN701
1 screw
(+PTT 2.6 u 6)
8
CDX-GT35U/GT39U/GT39UE
3-3.
MAIN BOARD
2 two screws
(+PTT 2.6 u 8)
4 two screws
(+P 2.6 u 8)
5 two screws
(+PTT 2.6 u 10)
1 three screws
(+BTT 2.6 u 5)
6 screw
(+P 2.6 u 8)
7 screw
(+PTT 2.6 u 10)
8 heat sink
9 MAIN board
3
3-4.
insulating sheet
SERVO BOARD
white
red
black
white
red
black
red
orange
blue
yellow
gray
2 toothed lock screw
(M 1.7 u 2.5)
SERVO board
3 toothed lock screw
(M 1.7 u 2.5)
1 Remove the eleven solders.
5 claw
7 SERVO board
6 optical pick-up (16 core)
(CN101)
4 claw
9
CDX-GT35U/GT39U/GT39UE
3-5.
CHASSIS (T) SUB ASSY
2 two screws
(M 1.7 u 2.5)
1 two screws
(M 1.7 u 2.5)
4 chassis (T) sub assy
3 claw
3-6.
ROLLER ARM ASSY
6 roller arm assy
5
1 spring (RAL)
4 gear (RA1)
3 washer
2 spring (RAR)
10
CDX-GT35U/GT39U/GT39UE
3-7.
CHASSIS (OP) ASSY
6 chassis (OP) assy
1 tension spring (KF)
5
7 two coil springs (damper) (natural)
8 coil spring (damper) (green)
4 slider (R)
3 lever (D)
2 gear (LE1)
3-8.
CHUCKING ARM SUB ASSY
3 chucking arm sub assy
1 spring
2
Note: Have this portion receive the chassis.
Note: Have this portion receive the chassis.
Note: Be careful not to touch the turn table.
11
CDX-GT35U/GT39U/GT39UE
3-9.
SLED MOTOR ASSY
2 three serration screws
(M 2 u 3)
3 sled motor assy
1 spring
turn table
spring
stand
Note:
Never remove these parts since they were adjusted.
bearing (F)
stand
Note: Place the stand with care not to touch the turn table.
bearing (R)
Note for Assembly
three serration screws
(M 2 u 3)
sled motor assy
Note: Take care to prevent the chassis from being bent
when tightening the three machine screws.
12
CDX-GT35U/GT39U/GT39UE
3-10. OPTICAL PICK-UP SECTION
2 optical pick-up section
1
Note: Be careful not to touch the lens and hologram
terminal when removing the optical pick-up section.
3-11. OPTICAL PICK-UP
1 tapping screw
(P 1.4)
2 leaf spring (OPS)
3 rack
5 optical pick-up
4 lead screw assy
13
CDX-GT35U/GT39U/GT39UE
MEMO
14
CDX-GT35U/GT39U/GT39UE
SECTION 4
DIAGRAMS
4-1.
BLOCK DIAGRAM – MAIN Section –
ELECTRONIC VOLUME
IC804
O/P SUB L 19
O/P SUB R 18
R-CH
J901
AUX
R-CH
7 AUX-LCH
9 AUX-RCH
R-CH (REAR/SUB)
ZAP BEEP R 13
J1
(ANTENNA)
O/P FL 23
PHASE LOCKED LOOP
(PLL)
IC001
L6
FM MIX
O/P RL 21
LOUT 8
ROUT 9
4 FMIN1
3 FMIN2
12 IN-FL
R-CH
R-CH
3 TU-LCH
4 TU-RCH
R-CH
5 CD-LCH
6 CD-RCH
11 IN-RL
O/P FR 22
O/P RR 20
R-CH (FRONT)
R-CH (REAR)
MUTE
Q104
I2C-SCK
I2C-SIO
I2C_SCK 25
I2C_SIO 26
X1
4MHz
I2C-SCK
I2C-SIO
RSSI 14
37 VSM
I2C-SCK
I2C-SIO
SA_OUT 71
SA_CLK 72
15 XTAL2
CN401
FLASH
PROGRAMMING
CDX-GT35U/GT39U/GT39UE
20
22
AU_LCH
11
12
28
8
17
18
TXD(MC-BUS)
RXD(MC-BUS)
WAKE UP
Z_MUTE
CD_ON
CDM_ON
3
25
7
SYS_RST
EJECT_OK
VBUS_ON
19
27
13
24
4
A_ATT
BU_CHECK
15
DR_+6V
AU_RCH
TX
4
RX
1
RESET
2
CLK IN
7
FLASH_W
3
UART_CLK
6
3.3V
4 SCL
2 SDA
5
AMP-REM 29
6
23
22
98
31
BATT
I2C-SCK
I2C-SIO
CD MUTE
Q305
BEEP 97
AMPSTB 68
DIAG 69
R-CH
FU601
VP 35
VP1 20
VP2 6
D308
16 BEEP
22 STB
25 DIAG
BU+B
AUDIO+B
SERVO+3.3V
MECHA+6V
PANEL+B
37
30
31
33
34
REAR/SUB
4
FR+
12
FR–
3
RR+
11
RR–
R-CH
D309
EXTATT_XEN 47
CN701
5
2
RL+
10
RL–
ANT-REM 27
16 XTAL1
AUDIO+ 8.5V
A+3.3V
BU_+3.3V
OUT-RL+ 9
OUT-RL– 7
BATT
SYSTEM CONTROL
IC401 (1/2)
I2C_SCK
I2C_SIO
ZAPPIN
ATT
CD
MECHANISM
UNIT
(MG-101Y)
(1/2)
CN802
1
FL+
9 FL–
D306
MUTE DRIVE
Q303,304
1 AMRFIN
SCL 18
SDA 19
MUTE
Q103
OUT-FL+ 5
OUT-FL– 3
R-CH
OPEN 15
PULL UP 16
L2
R-CH
I2C BUS CONTROLLED
POWER AMP/MULTIPLE
VOLTAGE REGULATOR
IC301
MUTE
Q102
8 AUX GND
-1
L
-2
R
J303
AUDIO
OUT
16
AMP-REM
ANT-REM
BATT
BU+5V
AUDIO +8.5V
SERVO+3.3V
MECHA+6V
PANEL+B
AEP,UK,RU MODEL
D701
BU+3.3V
MC_RX
MC_TX
WAKE_UP
Z_MUTE
CD_ON
CDM_ON
54
26
70
61
51
53
78
RESET
SYSRST
VBUS_ON
CLK_IN
MD2
MD0
FLASH_EN1
TEL ATT
DETECT
Q806
TEL_ATT 30
13
ACC DETECT
Q805
ACC_IN 29
BACK-UP
CHECK
D806,807,Q802,807,808
BU_CHECK 83
BATT
‡5&+LVRPLWWHGGXHWRVDPHDV/&+
‡6LJQDO3DWK
RESET
IC403
AUDIO+8.5V
SERVO+3.3V
BU+3.3V
MECHA+6V
59
60
58
62
27
28
1 VOUT
VIN 2
BU+3.3V
BU+3.3V
S401
RESET
4
+3.3V REG
IC402
: CD
5
BU+5V
: FM
: AM/MW/LW
: BUS AUDIO
: AUX
‡$EEUHYLDWLRQ
585XVVLDQPRGHO
FLASH
PROGRAMMING
BUFFER
Q401,402,701
BU+3.3V
15
15
7
TEL-ATT
ACC
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
4-2.
BLOCK DIAGRAM – DISPLAY Section –
SYSTEM CONTROL
IC401 (2/2)
39 KEY_IN1
KEY MATRIX
LSW901
S902–908
LCD_SO 49
LCD_SCK 50
LCD_CE 48
40 KEY_IN0
46 KEY_ACK1
LCD DRIVER,LED CONTROL
IC901
64 DATA
63 CLK LCD
62 CE
SEG48
I
SEG2
‡
SEG52
RE901
PUSH ENTER/SELECT
(VOLUME)
5
|
50
‡
55
‡
60
COM4 51
|
I
COM1 54
RE0
RE1
ROTARY
ENCODER
11 RE_N0
12 RE_IN1
PANEL+B
LCD901
DIMMER
SWITCH
Q901
DIMMER 2
AEP,UK,RU MODEL
LCD BACK LIGHT
DRIVE
Q902
BACK-LIGHT 1
34 RC_IN1
41 RC_IN0
J801
(REMOTE IN)
LED911,913–915,918,
924,925,930,931,
LSW901,905–913
LED901
(LCD BACK LIGHT)
LIQUID
CRYSTAL
DISPLAY
PANEL
45 KEY_ACK0
E,AR MODEL
BU+3.3V
S402
FREQUENCY
SELECT
USB POWER
CONTROL SWITCH
IC503
FM(200K)
AM(10K)
55 AREA_SEL2
BATT
FM(50K)
AM(9K)
USB POWER
SWITCH
Q502
SWITCHING
REGULATOR
Q503
USB POWER
CONTROL
Q501
X402
32.768kHz
X401
7.92MHz
REMOTE
CONTROL
SIGNAL
RECEIVER
IC902
14 XIN
13 XOUT
1 VIN
VOUT 3
CONT
2
VBUS
DC/DC CONVERTER
IC501
DD_ON 100
D502
1 RC
SYNC_OUT 99
DRV 6
D505
D510
‡ SLJQDO PDWK
93 OSCIN
: USB
D512
92 OSCOUT
‡ AEEUHYLDWLRQ
RU : RXVVLDQ PRGHO
AR : AUJHQWLQD PRGHO
USB_ON 21
USB OVER
CURRENT DETECT
D511,Q504,505
USB_OVER 24
3
L502
95 SIRCS
7 NOSE_SW
VBUS
CD
MECHANISM
UNIT
(MG–101Y)
(2/2)
CDX-GT35U/GT39U/GT39UE
16
16
USB D+
USB D–
D+
D–
1
3
2
4
CN902
(USB)
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
For Printed Wiring Boards:
For Schematic Diagrams:
Note:
• X : Parts extracted from the component side.
• Y : Parts extracted from the conductor side.
•
a : Through hole.
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Note:
• All capacitors are in μF unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : Internal component.
• C : Panel designation.
Caution:
Pattern face side:
(SIDE B)
Parts face side:
(SIDE A)
Parts on the pattern face side seen
from the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Abbreviation
RU
: Russian model
AR
: Argentina model
CDX-GT35U/GT39U/GT39UE
• Waveforms
– MAIN Board –
1 IC401 qd (X_OUT)
1.8 Vp-p
32.768 kHz
Note: The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
1 V/DIV, 20 ȝsec/DIV
2 IC401 os (OSC_OUT)
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM/MW/LW
<
> : CD PLAY
* : Impossible to measure
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
J
: CD
F
: FM
f
: AM/MW/LW
L : AUX
c : USB
• Abbreviation
RU
: Russian model
AR
: Argentina model
3.2 Vp-p
7.92 MHz
2 V/DIV, 50 nsec/DIV
3 IC001 qh (XTAL1)
0.05 Vp-p
4 MHz
0.05 V/DIV, 50 nsec/DIV
17
17
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
4-3.
PRINTED WIRING BOARD – MAIN Section –
2
1
3
•
: Uses unleaded solder.
4
5
6
7
8
9
10
11
12
13
J303
AUDIO OUT
REAR/SUB
A
-1
L
J1
(ANTENNA)
B
JW220
C305
JW224
JW218
C811
JC101
36
JC129
C304
IC301
C405
R217
R117
R207
JW225
C213
JC112
C113
C315
CN802
R826
FU601
C810
2
9
16
C524
R824
JW203
JC107
JW204
BCE
ECB
JL028
15
1
R709
JL033
C434
S401
RESET
X401
A
KEY BOARD CN901
18
R466
C436
JL034
JL035
R463
CD MECHANISM
UNIT
(MG-101Y)
(1/2)
D505
D512
R521
JL042
D510
R503
R520
BCE
R409
R406
1
JW327
C516
IC503
FLASH
PROGRAMMING
1
BCE
R431
JW252
JW281
C518
8
JW233
Q505
5
CN401
R510
D511 Q504
JW229
C503
C514
C521
R512
5
C507
R518
R464
JW210
L502
D504
DD S
DD G
C504
C506
R504
R514
8
4
R516
R517
C509
C508
D502
R528
ECB
R505
JC103
JW330
1
Q502
R508
R511
Q503
IC501
C505
JW251
JL030
C435
R714
FB707
BCE
Q501
R468
R467
R424
JW260
JW246
JW301
R432
JW245
JW243
JW244
C418
JW239
R501
R502
F501
D503
C707
JW248
JW268
R421
18
Q807
Q808
C501
Q802
C502
JL027
JL014
D806
R827
ECB
JL026
JL013
L501
D807
ECB
JL012
R815
JL025
R816
JL024
JL011
JW269
R707
BCE
JL010
JL031
JL023
JW206
JL022
JL009
JW205
JL008
R706
R461
R460
JC105
JL021
JL032
JL007
JW270
R713
JL020
JW300
JW299
C703
JL019
JL006
C706
JL015
JL001
JW277
C704
BCE
C705
C702
R427
R426
JW249
JC106
R434
R435 JW247
R429
R428
R430
R423
R420
JL005
FB705
C201
C101
D308
JW267
D309
R437
C425
31
30
0
JL018
JW250
AEP,UK,RU
MODEL
L503
JL017
JL004
R712
JW278
JW298
JW271
JW264
JW263
JW275
C426
JW316
R438
X402
R405
R600
JW215
C519
(Page 22)
CDX-GT35U/GT39U/GT39UE
R822
R821
JC130
JW234
JC133
JW282
JW261
JW302
R447
51
50
C401
10
1
C417
JL003
R710
D404
D403
C807
JW217
JW216
D205
JW235
JW307
JW257
JC127
81
R411
GT35U/GT39U
R417
R413
14
JL016
D701
S401
19
1
R801
R825
JW212
D104
D105
JW207
JW209
JW208
JW219
C404
JW236
C523
E,AR MODEL
R414
28
Q701
JW313
20
2
CD MECHANISM
UNIT
(MG-101Y)
(2/2)
R101
Q305
JW274
AEP,UK,RU
MODEL
R419
JC128
CN403
J
R306
GT39UI
R412
C422
C420
C419
R416
R407
R818
JW214
C513
JW317
JW286
R201
FB301
JW310
D201
C520
JW285
JL041
R410
X401
C804
JL002
R433
JW238
JW240
C421
JL040
C416
D401
D410
JW287
Q805
R704
R441
E,AR
MODEL
JW284
D411
R304
JW211
JW221
I
ECB
C105
R302
JW289
R526
3
CAM003
R465
JW283
JW294
1
0
C4
JW242
D101
R527
C205
C701
JW273
GT35U/GT39U
C413 JL039
JW241
R203
R446
R703
JW253
C424
C423
C429
JC104
D301
1
R311
R452
R451
I
R408
CN501
JW293
R444
C428
R455
JL038
JW292
JW321
C204
R404
H
C323
R204
R103
R303
C104
C301
C302
R442
R443
JL037
R402
JC124
R104
JC110
JW311
S402
R717
80
-1
Q402
-2
C427
R450
GT39UI
E,AR MODEL
R456
JW309
G
4
3
R523
JW329
R14
FB701
R422
R445
FM(200K)
AM(10K)
1
2
R524
JW126
R13
R401
JW322
A002
JC109
FM(50K)
AM(9K)
S402
FREQUENCY
SELECT
JC108
E,AR MODEL
L1
JW102
JW266
X1
R6
R453
JC125
JW312
R439
GT35U:AEP
UK,RU/GT39U
R448
R454
R440
FB702
JW276
JW254
JW297
JW306
C28
C803
JW280
JL029
JW265
JW295
JW296
JW314
JW272
JW304
JW303
JC126
JW305
Q806
JW213
R820
CN701
JL036
AEP,UK,RU
MODEL
L801
D812
R817
R819
AEP,UK,RU MODEL
JW228
C402
EXCEPT E MODEL
C808
R823
R701 JW262
JW315
L301
D303
D809
R449
C307
5
4
JW255
C322
BCE
C306
JC123
1
D808
AEP,UK,RU
MODEL
D305
D302
C433
JW256
R313
D306
BCE
JC122
C317
JW319
JW328
D304
JW279
3
C815
C403
R525
R10
R832
ECB
Q401
C18
F
IC402 JW259
ECB
C319
C316
Q303
R831
JW323
R12
17
Q304
JW324
C27
16
C409
C311
C407
IC403
C17
R309
C22
JW147
JC131
C805
D810
C312
JC113
AEP,UK,RU MODEL
JC102
AEP,UK,RU
MODEL
C411
JW308
C23
C25
C26
JW148
JC119
JW318
C318
C9
C21
C24
R11
IC001
R4
R5
C16
C314
R308
D813
C806
C309
C313
Q103
JC115
R833
32
1
C203
C20
A001
L7
L8
C12
C19
C308
JC121
15
FB201
FB101
14
C5
C303
JC118
IC804
L6
C8
C210
R212
C208
R112
C108
JC132
28
1
D204
JW237
JW202
JW222
D811
AEP,UK,RU
MODEL
JW232
C110
JW201
8
JW231
R113
C103
D
ECB
BCE
ECB
BCE
R116
C206
C813
C812
1
C211
JC114
R3
37
C406
JW230
C209
C109
C217
C6
C1
R15
R16
R2
L2
C13
C112
JC120
JC116 JW288
C106
Q203
R213
R216
R206
R106
JW137
JC100
R222
E
C212
JW258
JW138
R1
VR1
C
Q204
Q104
11
CAM002
Q202
C1
BCE
Q102
1
R802
JC117
DDS
DDG
R107
C215
C214
JC111
JW226
C207
C115
C114
JW227
C107
C216
R830
C116
R829
E MODEL
J801
(REMOTE IN)
-2
R
CAM001
R459
R462
12
1-880-411-
(12)
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
SCHEMATIC DIAGRAM – MAIN Section (1/3) –
1
2
3
• See page 24 for IC Block Diagrams.
4
5
6
7
8
9
10
11
12
MAIN BOARD (1/3)
15
16
IC B/D
IC301
E MODEL
P-GND4
DIAG
RST
ANT-REM
CRES
AMP-REM
AUDIO+B
SERVO+3.3V
GND
MECHA+6V
PANEL+B
VP
CBU
BU+B
30
31
32
33
34
35
36
37
R815
15k
C810
0.22
6.4
16
BATT
D807
MAZ8180GMLS0
6
3
4
1
2
D810
MAZ8180GMLS0
5
GND
R817
47k
BATT
6.4
Q807
RT1N141C-TP-1
0
R821
10k
C803
0.47
R822
47k
AEP,UK,RU
MODEL
C807
3300
16V
D104
1A4-A2
C808
0.22
R820
10k
C804
0.47
2.7
0.6
R819
47k
R827
220k
0
R818
4.7k
F
0.6
5.1
10.6
6.2
13.7
3.3
D302
1A4-A2
C304
0.22
D105
1A4-A2
AEP,UK,RU
MODEL
D304
1A4-A2
C309 C313
10
10
16V 16V
D204
1A4-A2
D303
1A4-A2
D305
1A4-A2
25
26
27
Q806
2SC3052EF-T1-LEF
TEL-ATT DETECT
8
C308 C311
0.01 0.01
R816
1k
28
29
R306
47k
C314
47p
R308
150
30
C315
2.2
31
BUS6
0
Q805
2SC3052EF-T1-LEF
ACC DETECT
7
C305
0.22
C116 C216
100p 100p
L301
8
C307 C312
47
10
16V 16V
C811
0.22
0
Q802
RT1N141C-TP-1
C211
100p
C306
1
2.2uH
D806
MAZ8075GMLS0
C111
100p
0<3.3>
0
D205 1A4-A2
R825
1
4.7k
C210
R823
AEP,UK MODEL
14
OUT-FR-
29
14.4
STB
28
8.6
OUT-FR+
27
13.7
VP1
26
7.1
OUT-RR-
25
3.3
P-GND3
24
7.1
OUT-RR+
23
7.1
BEEP
22
7.1
IN-RR
21
8
IN-FR
20
7.6
19
1
1k
Q808
2SC3052EF-T1-LEF
ANT REM
18
C209
R824
Q802,807,808
BACK-UP CHECK
ACC
S-GND
FL+
1
17
7.6
2
IN-FL
RL+
FR-
IN-RL
RR+
4
3
16
7.6
5
FR+
SVR
AMP-REM
15
JC111
0
16
14
1
8
13
C215
GND
BATT
12
7.6
6
OUT-RL+
7
ANT-REM
P-GND1
8
ACC
OUT-RL-
9
GND
11
JC112
0
15
10
8.2
7
ACC
VP2
10
FL-
OUT-FL+
RL-
9
7.1
14
8
7.1
6
7
14.4
ANT REM
SCL
11
OUT-FL-
RR-
6
7.1
13
5
3.1
5
SDA
12
4
7.1
13
FR-
TAB
TEL-ATT
3
1
15
AMP REM
12
2
C214
7
4
1
1
14
FRONT +
R-CH -
AEP,UK,RU MODEL
C115
6
14
1
13
15
ILL
C114
5
TEST
11
1
12
3
D813
1A4-A2
25V
4
RR-
REAR +
R-CH -
R830
0
L801
22
11
16
C109
GND
3
RL-
+B
-
14.4
1
ACC
10
17
C110
ANT REM
2
18
+B
C303
AMP REM
9
FL-
+B
FU601
10A
I2C_SCK
FR+
ATT
1
RR-
10
19
I2C_SIO
RR+
2
2
-
+B
D812
1N5404-C311-3
C
1
+
9
D808
MAZ8180GMLS0
RL+
4
FR-
REAR
L-CH
1
1000p
FL+
3
FL-
+
D809
MAZ8180GMLS0
RR+
6
CN802
16P
FRONT
L-CH
C806
B
5
RL-
1000p
FR+
8
D811
MAZ8180GMLS0
FL+
7
C805
RL+
3.1
EXCEPT E MODEL
E
14
IC301
TDA8588AJ/N2/R1 (E,AR)
TDA8589AJ/N2/R1 (RU)
TDA8589AJ/N2/R1/M5 (AEP,UK)
I2C BUS CONTROLLED POWER AMP/
MULTIPLE VOLTAGE REGULATOR
A
D
13
14.4
4-4.
32
Q304
RT1P141C-TP-1
13.9
0
D306
MA2J1110GLS0
R313
22
Q305
RT1P141C-TP-1
CD MUTE
3.3
0
D308
MA2J1110GLS0
C322
47
16V
13.6
33
Q303,304
MUTE DRIVE
0
0.01
0.22
C406
C433
47
16V
C405
Q303
RT1N141C-TP-1
0.22
D309
MA2J1110GLS0
3.3
C404
G
AEP,UK,RU MODEL
R826
0
C411
10V
1
0.01
2
VIN
3
330
C815
1000p
C409
10V
C402
0.1
1000
C401
0.01
IC402
TK11133CSCL-G
+3.3V REG
R832
10k
C407
1
3.3
CONT
VOUT
C403
330
6.3V
R401
100k
3.3
GND
VSS
2
4.8
4
VIN
S401
RESET
ATT
TEL
NC
5
RC1
RC0
ACC
I
3
4
NOISE VOUT
IC402
IC403
PST8228UL
RESET
1.3
IC B/D
IC403
5.1
3.3
H
R802
0
J801
(REMOTE IN)
R801
0
1
MAIN BOARD
(2/3)
(Page 20)
CDX-GT35U/GT39U/GT39UE
19
19
18
BUS2
17
16
15
14
13
12
11
10
9
7
8
6
5
4
3
2
1
J
2
MAIN
BOARD
(3/3)
(Page 21)
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
4-5.
SCHEMATIC DIAGRAM – MAIN Section (2/3) –
1
3
2
• See page 17 for Waveforms.
5
4
6
• See page 24 for IC Block Diagrams. • See page 26 for IC Pin Function Description.
7
8
9
10
11
12
13
14
15
16
(Page 19)
MAIN BOARD
(1/3)
17
BUS2
18
16
10
15
13
11
12
8
2
7
6
3
5
14
9
1
4
1
A
19
MAIN BOARD (2/3)
20
XFLASH
100k
R447
100k
100k *1 R451 100k
*1 R449
R448
0.1
TEL_ATT
10k 0.5%
10k 0.5%
R441
100
KEY0
R437
100
KEY1
C426
1000p
C427
1000p
3.3
C423
0.01
R435
100
3.3
R434
100k
C425
1000p
ATT
0
R409
10k
2.2k
R427
2.2k
R428
100k
R429
100k
Q504,505
USB OVER CURRENT DETECT
100k
R432
100k
R431
100k
100k
R406
ZAPPIN
BUS4
R430
C514
330
10V
C434
J
0.01
C435
0.1
C436
0.01
SYNC_OUT
R466
0
MC_TX
CLK_IN
MC_RX
UART/CLK
BUS5
XFLASH
RE1
RE0
NOSE_SW
SIRCS
TEL
AEP,UK,RU
MODEL
R505
0
JL035
R464
100
JL034
R463
100
JL033
R462
100
JL032
R461
100
JL031
R460
100
JL036
JL030
JL029
K
L503
10uH
C523
100
10V
CDX-GT35U/GT39U/GT39UE
(Page 21)
SA_IN
RC1
3
MAIN
BOARD
(3/3)
3
22
C424
0.01
0
ACC_IN
CDM_ON
0
CD_ON
SYS_RST
0
3.2
3.3
BUS_ON
I2C_SCK
USB_OVER
0
RC0
R438
100
3
I2C_SIO
3.1
USB_ON
3.1
UNISO
UNISI
UNISCK
3.3
LCD_CE
AEP,UK,RU
MODEL
Q505
RT1N141C-TP-1
R505
1k
DD_ON
R440
MD2
MD1
MD0
RESET
AREA_SEL2
WAKE_UP
AREA_SEL1
AREA_SEL0
MC_RX
MC_TX
NCO
CLK_IN
Z_MUTE
VCC
TEST
0
1.9
LCD_DATA
2.2k
0.5
R426
3
R516
100k
0.5%
R517
22k
0.5%
C519
1
2.2k
R442
3.3
3.3
AVCC 32
ATT 31
E,AR MODEL
R433 100k
0
C421 0.01
R422
100
C
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
VSS
8
R420
100
D511
MA2J1110GLS0
VSS
7
JL041
0
NCO
AMP_STB
DIAG
6
VCC
VADJ
GND
NCO
5
10k 0.5%
0
3
3
0 *2 R450 100k
3.3
3.2
0
0
3.3
3.3
3.3
3.3
3.3
R456
0
0
3.3
3 *5 R454 100k
0 *3 R452 100k
100 *4 R453 100k
10k
R455
R402
4
R439
MC_TX
MC_RX
WAKE_UP
CLK_IN
Z_MUTE
SA_DA
SA_CLK
0
3
3.3
VOUT
1.3
5.1
VIN
CONT
3.3
5.6
2
ACC
I
1
R503
12k
C516
0.1
Q504
RT1N141C-TP-1
R518
56k
0.5%
R514
330k
C509
15p
D401
LRB751V-40T1G
CDM_ON
D502
MA2J1110GLS0
C507
1
100k
CD_ON
R510
100k
R408
R520 R521
10k 3.3k
0.5% 0.5%
1
CYRIL_SEL
99 SYNC_OUT
100 DD_ON
I2C_SCK
C508
1500p
3.3
I2C_SIO
4
1.6
1
3
0
R424
GND
FB
2
R407
0
D512
MA2J1110GLS0
0.7
1
IC501
TPS40200DRG4
DC/DC
CONVERTER
R467
100k
C505
470p
12.8
14.4
DRV
COMP
IC501
SS
IC B/D
C513
0.1
0
SYNC_OUT
DD_ON
R468
C504
0.1
3.3
5
5
C518
220
10V
1
6
4
RC_IN1 34
AVRH 33
C422
C503
1
D
2
12.8
7
R504
68k
C502
120
16V
D
3
8
0.5
H
D
ISNS
14.4
Q501
RT1N141C-TP-1
USB POWER CONTROL
3.3
G
C521
470p
R512
0
14.4
3
QUALITY 36
AVSS 35
2.2k
R443
3.3
SA_IN 38
VSM 37
97 BEEP
98 ZAPPIN
LCD_CLK
R444
C428
1000p
RC_IN0 41
KEY_IN0 40
KEY_IN1 39
95 SIRCS
96 NCO
GT39UE
R412 100k
C506
470p
1
1.2
0
R501
56k
D
2
D
6
VCC
D
7
RC
G
S
2
VSS 44
NCO 43
NCO 42
93 OSC_IN
94 NCO
GT35U
/GT39U
R411 100k
R511
1.5k
3
G
D
5
1
D510
MAZ8039GLLS0
D
4
56k
R502
C501
0.1
S
6
L502
68uH
D505
MAZ8056GMLS0
5
Q503
RSQ035P03TR
SWITCHING REGULATOR
14.4
3.3
R508
0
D503
MAZ8120GMLS0
4
F501
2A
3.2
LCD_SCK 50
3.1
LCD_SO 49
0.2
48
LCD_CE
3.3
EXTATT_XEN 47
3.3
KEY_ACK1 46
3.3
KEY_ACK0 45
IC401
MB90F882PF-G-103E1
SYSTEM CONTROL
2
X_IN
1.2
0
D504
MA24D5000BS0
Q502
TPC6108(T5RSONYF,M
USB POWER SWITCH
14.4
14.4
3.8
F
100k
1.9
91 VSS
92 OSC_OUT
X_OUT
X401
7.92MHz
IC503
NJM2387ADL3(TE2)
USB POWER CONTROL SWITCH
0
1.5
R410
1.1
IC B/D
3
L501
47uH
S402
FREQUENCY
SELECT
FM(200K)
FM(50K)
AM(10K)
AM(9K)
IC401
89 NCO
90 VCC
33p
0
IC503
87 NCO
88 NCO
3.3
X402
32.768kHz
C416
0.01
Q701
RT1N141C-TP-1
FLASH PROGRAMMING BUFFER
-2
85 NCO
86 NCO
27p
3.2
C413
1000p
D701
LBAT54ALT1G
C420
E
100k
C419
R710
JL040
R600
100k
BUS3
R445
100k
83 BU_CHECK
84 EQ TYPE_SEL
RE_IN1
JL028
0
R405
220k
JL027
81 NCO
82 TU_ATTIN
RE_IN0
FB707
2.7
VBUS_ON
JL039
R465
0
BU_IN
SA_OUT
0
3.3
FB705
R714
C707
0.01
100
1
JL026
C703
10
16V
R423
2
NCO
JL025
100k
3.3
NCO
JL024
R713
NCO
3
VBUS_ON
JL023
10k
SYS_RST
Z_MUTE
JL022
R421
BU_3.3V
4
100
JL021
C429
0.01
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
0.01
5
R709
MC_RX
C417
BU_GND
0
TU_ATT
NCO
6
100
R712
MC_TX
SA_CLK
7
R707
JL020
0.01
NCO
8
JL019
C706
NSMASK
Z-MUTE
VBUS_ON
100
NCO
D
R706
-1
NOSE_SW
9
JL018
*1 R449,451 (GT39UE)
*2 R450
(GT35U:AEP,UK,
RU/GT39U)
*3 R452 (GT35U/GT39U)
*4 R453 (AEP,UK,RU)
*5 R454 (E,AR)
E,AR MODEL
NCO
10
FB702
JL017
0
11
D_GND
Z/Y_CHECK
C705
0.01
JL016
100k
TXD(MC_BUS)
C702
22
16V
JL015
R419
12
JL014
0.01
13
JL013
C418
AUDIO_8.5V
RXD(MC_BUS)
CD_ON
RDS_ON
14
JL012
3.3
Q402
RT1P141C-TP-1
FLASH PROGRAMMING BUFFER
R446
100k
NCO
15
CDM_ON
JL037
16
DR_6V
560p
FLASH_EN0
DR_GND
USB_GND
C101
JL011
FLASH_EN1
17
JL010
ILLUMI_SEL
CD_ON
3.3
0
COL SW_SEL
18
0
560p
3
CDM_ON
R704
C201
FB301
100k
19
1k
R417
A_ATT
R101
JL008
JL009
Q401
RT1N141C-TP-1
FLASH
PROGRAMMING
BUFFER
FB701
2.2uH
R717
0
C704
0.01
JL038
20
1k
3.3
AU_LCH
R201
NCO
21
JL007
NCO
CD MECHANISM
UNIT
(MG-101Y)
(1/2)
22
JL006
0
3
B-OUT_SEL
C
AU_RCH
AU_GND
C701
100
10V
JL005
3
23
0
A_GND
JL004
100k
24
100k
25
A_3.3V
BU_IN
E,AR MODEL
EJECT_OK
WAKE_UP
R416
26
0
JL003
R414
OPEN_REQ
100k
100k
27
R703
R701
JL002
R413
BU_CHECK
JL001
XFLASH
B
28
UART/CLK
CN701
28P
WAKE_UP
VBUS_ON
21
20
20
R459
100
CN401
8P
1
RESET
2
CLK_IN
3
UART_CLK
4
Ucom-TX(CD-RX)
5
Ucom-RX(CD-TX)
6
3.3V
7
FLASH_W
8
GND
23
R523
1k
R524
1k
4
R525
1k
24
FLASH
( PROGRAMMING )
MAIN
BOARD
(3/3)
(Page 21)
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
4-6.
• See page 17 for waveforms. • See page 24 for IC Block Diagrams.
SCHEMATIC DIAGRAM – MAIN Section (3/3) –
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
MAIN BOARD (3/3)
A
J303
2P
C107
100p
C207
100p
C113
100p
C213
100p
L
-1
R
33
Q203
RT1N140C-TP-1
R212
1k
0
0
R213
10k
SA_CLK
R207
10k
R116
220
R206
220
C112
10
50V
C206
10
50V
0
R107
10k
R106
220
C106
10
50V
SA_DA
SA_IN
Q103
RT1N140C-TP-1
30
0
R113
10k
0
R831
10k
C212
10
50V
C208
10
50V
R112
1k
29
D
R216
220
0
R117
10k
R217
10k
25
(Page 19)
0
Q202
LTC614TKFP8T146
0
0
0
Q104
LTC614TKFP8T146
Q204
LTC614TKFP8T146
B
0
Q102
LTC614TKFP8T146
0
Q102-104,202-204
MUTE
2
J303
AUDIO OUT
G
28
MAIN
BOARD
(1/3)
REAR/SUB
-2
26
27
C
L
R
C108
10 50V
BUS6
R309
10
C812
1
I2C_SCK
FB201
C813
1
I2C_SIO
FB101
L1
C316
0.1
E
ZAPPIN
R311
47k
C317
220
16V
3.3uH
IC001 IC B/D
C28
47
16V
R829
0
IC001
TEF6617T/V1/S470,518 (E,RU,AR)
TEF6617T/V1/S470/M5,518 (AEP,UK)
PHASE LOCKED LOOP(PLL)
20
17
C103
2.2
50V
BUS3
R303
1.5k
C302
47p
C318
1
R14
100
3.1
I2C_SIO
R13
100
3.1
C27
0.1
3.4
R12
22
R302
2.2k
21
F
I2C_SCK
22
19
0
0
4.1
4.1
MAIN
BOARD
(2/3)
3
4.1
4.1
(Page 20)
4.1
4.1
8.2
H
3.1
3.1
15 OPEN OPEN 14
16
17
18
19
20
21
22
23
PULL UP
ZAP BEEP R
OPEN
ZAP BEEP L
O/P SUB R
OPEN
O/P SUB L
OPEN
O/P RR
AUX_RCH
O/P RL
AUX_GND
O/P FR
AUX_LCH
O/P FL
CD_RCH
13
12
9
3.3
8
7
6
3.3
3.7
24 VCC CD_LCH 5
3.7
I2C_SCK
4
TU_RCH
I2C_SIO
3
TU_LCH
3.7
25
26
C25
C217
10
50V
C24
18 SCL
XTAL2 15
19 SDA
RSSI 14
MPXOUT
13
20 VREF
VREGSUP
7.3
21
MPXIN 12
VCC1
8.6
22
11
AMIFAGC2
C205
1
50V
C323
2.2
50V
0.1
R11
0.1
4.7k
C23
R203
470
R204
12k
R104
12k
C204
100p
C104
100p
C301
1000p
3.7
3.7
0.01
10
GNDAUD
24 VCODEC
9
ROUT
25 PLL
26
0 (1.2)
C21
1
C20
0.01
C19
0.01
0 (1.2)
1.3 (2.9)
8.6 (7)
8.6 (7)
28
29
30
31
32
LOUT 8
PLLREF
AMRFAGC
27 TEST
560uH
L7 560uH
R404
0
2.1
0.01
L8
R103
470
5.6
2.6 (4.6)
C22
C105
1
50V
IC B/D
11
10
27 A-GND FIL C 2
3.6
3.6
XTAL1 16
6.3
3
X1
4MHz
6.3
C18
12p
0.7 (1)
R10
33k
R6
68k
3.9 (4.9)
3.6
C17
0.1
0.3 (2)
C16
0.47
JW147
JW148
23 GND
R222
0
R833
0
D301
UDZSUSTE-176.8B
IC804
BD3705FV-E2
ELECTRONIC VOLUME
0
G
C203
2.2
50V
IC804
C319
10
50V
C26
0.1
JC1000
0
GNDD
VCC2 6
AMSELIN1
GNDRF
AMSELIN2
FMIN1
AMIFAGC1
FMIN2
AMSELOUT1
AMRFDEC
AMSELOUT2
AMRFIN
JW126
7
3.8
R5
0
3.8
R4
0
0.5 (1.8)
C13
2.2
CAM002
(CHASSIS)
8.6
C9
0.1
5
4
3
2
1
L6
FM MIX
C8
33p
3
3.1 (2.9)
3.1 (2.9)
0 (4.1)
4
VR1
2
1
C12
6
R15
0
C6
15p
R16
0
C1
1000p
JW137
31
JW138
32
0.22
C5
1000p
0 (1.3)
R3
0
L2
2.2uH
R2
470k
JW102
J1
(ANTENNA)
R1
470k
CN403
20P
1 GND
2 USB_VBUS
D201
3
GND
4
USB_GND
D101
5
KEY_GND
6
USB_D+
7
AUX_LCH
8
USB_D-
28 OPEN OPEN 1
KEY1
RE1
I
R304
KEY0
BUS4
C524
0.1
23
MAIN
BOARD
(2/3)
0
RE0
BUS5
J
9
SIRCS
LCD_DATA
18 LCD_DATA
19 ILL+B
NOSE_SW
D411
0.1
(Page 20)
CAM003
(CHASSIS)
24
K
CDX-GT35U/GT39U/GT39UE
21
21
(Page 23)
KEY
BOARD
CN901
16 SIRCS
17 LCD_CLK
LCD_CLK
4
A
12 AUX_GND
13 RE0
14 KEY0
15 LCD_CE
LCD_CE
C520
100 10V
KEY1
10 AUX_RCH
11 RE1
20 PANEL(NOSE SW)
D410
MAZ8068GMLS0
D403
MAZ8068GMLS0
R527
D404
MAZ8068GMLS0 10
R526
10
CN501
3P
1
USB_D+
2
USB_D-
3
USB_GND
CD MECHANISM
UNIT
(MG-101Y)
(2/2)
CDX-GT35U/GT39U/GT39UE
4-7.
PRINTED WIRING BOARDS – KEY Section –
2
1
3
•
: Uses unleaded solder.
4
5
6
7
8
9
10
11
12
13
14
KEY BOARD (SIDE A)
LED907,S907 LED907
OFF
S907
LED913
LED911
LED914
52
R947
S903
IC902
LSW912
R964
LSW911
LSW910
D
LED925,930,S903
IC902
LED918,924,S904
MODE
LSW913
ZAP
LSW911
1
/ALBM–
LSW912
AF/TA
/PTY
(EXCEPT E MODEL)
LSW909
LSW908
LSW909
3
/REP
LSW910
2
/ALBM+
R929
LSW907
R963
4
LSW908
4
/SHUF
LSW906
R955
R928
LSW913
3
R959
1
R930
LED918
2
S904
LED901
(LCD BACK LIGHT)
R931
R925
C906
R926
S902
LED931
LED931,S902
m
.
SEEK–
R924
LCD901
LIQUID CRYSTAL DISPLAY PANEL
LED924
S908
LED901
R951
LED915,S908
LED930
R943
LED915
C
LSW901
Z
S906
S905
LED925
B
LED914,S905
SEEK+
>
M
LSW901
LED911,913,
S906
SOURCE
R936
A
LSW905
LSW907
5
/DM+
31
1-877-707-
(31)
LSW905
DSPL
/SCRL
LSW906
6
/PAUSE
BTM
(E MODEL)
J901
AUX
E
JACK BOARD
MAIN BOARD CN403
A
KEY BOARD (SIDE B)
ORG
W001
FB901
31
VDR903
D911
D910
R935
RE901
PUSH ENTER/SELECT
(VOLUME)
CN902
1
CN902
4
(USB)
L901
VDR906
VDR900
R907
R906
VDR908
R911
33
32
VDR901
R909
16
17
RB901
D912
D908
E
R910
D909
IC901
R993
R998
D907
49
48
C903
64
D906
1
2
W004
R920
I
W002
1
20
R908
D901
R990
R986
R922
R987
C902
C904 C901
R989
R948
R940
R921
H
R939
R923
RED
CN901
D902
B
Q901
RE901
R988
R933
R991
Q907
R992
B
R944
Q902
19
R932
R904
E
R952
R905
E
B
R996
R934
R967
R968
R927
G
W003
1-877-708-
R914
F
BRN
FB902
FB903
(Page 18)
ORG
W006
RED
W005
BRN
31
1-877-707- (31)
CDX-GT35U/GT39U/GT39UE
22
22
(31)
CDX-GT35U/GT39U/GT39UE
4-8.
SCHEMATIC DIAGRAM – KEY Section –
1
3
2
4
6
5
7
8
10
9
11
13
12
14
KEY BOARD
6
AUX_GNO
4
2
VDR908
LSW906
6/PAUSE
S907
OFF
R936
*3
LED907
*1
OFF
3
5
1
D906
MAZ8180GMLS0
D910
MAZ8068GMLS0
D907
MAZ8068GMLS0
D908
MAZ8068GMLS0
D909
MAZ8068GMLS0
R922
1k
S905
SEEK+
LSW907
5/DM+
5
R908
180
2
R909
180
C904
0.47
4
2
LSW908
4/SHUF
R924
1.5k
5
VDR903
4
FB903
W003
W005
AUX_RCH
W002
W006
AUX_GNO
*3 R936
150 (GT35U)
180 (GT39U/GT39UE)
SEEK-
R925
1.8k
S903
LSW909
3/REP
3
1
6
4
2
R932
1.5k
LSW910
2/ALBM+
*6 R943,955,963,967
100 (GT35U)
75 (GT39U/GT39UE)
S904
MODE
5
3
1
6
4
2
R914
0
LSW911
1/ALBM-
RE901
PUSH ENTER/SELECT
(VOLUME)
R951
*4
R947
*4
LED918
*1
MODE
LED925
*1
LED924
*1
MODE
LED930
*1
LED913
*1
SOURCE
R939
*4
R943
*6
LSW912
AF/TA
(EXCEPT E MODEL) /PTY
LED914
*1
SEEK+
(E MODEL)
3
1
6
4
2
5
3
1
6
4
2
R934
2.2k
R948
*5
R940
*5
BTM
R968
*7
LED915
*1
LSW913
ZAP
LED931
*1
R952
*5
R933
1.8k
R967
*6
LED911
*1
SOURCE
SEEK-
R944
*7
R991
3.3k
5
3
1
6
4
2
23
C902
C901
S[5]
S[6]
S[7]
S[8]
S[9]
S[10]
S[11]
S[12]
S[13]
S[14]
S[15]
S[16]
S[17]
S[18]
S[19]
S[20]
0.1
0.1
S[1]
R988
R989
R990
100
100
100
2.6
4.7
0.2
3.2
3.1
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
SEG4
SEG3
COM4
COM3
COM2
COM1
SEG2
VDD
VDD1
VDD2
VSS
SEG52
INH
LCD_CE
LCD_CLK
LCD_DATA
IC901
IC901
LC75829PWH-US-H
LCD DRIVE
1
2
3
R993
10k
0.8
Q901
2SC3052EF-T1-LEF
0.1 DIMMER SWITCH
4
5
6
7
8
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
SEG30
SEG31
SEG32
SEG33
SEG34
SEG35
SEG36
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
S[21]
S[22]
S[23]
S[24]
S[25]
S[26]
S[27]
S[28]
S[29]
S[30]
S[31]
S[32]
S[33]
S[34]
S[35]
S[36]
9 10 11 12 13 14 15 16
R992
10k
0.1
0.8
R996
10k
52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
5
R987
0
C903
0.1
2.6
2.6
2.6
2.6
2.6
2.6
2.6
5.2
3.5
1.8
Q907
2SC3052EF-T1-LEF
R964
*7
R927
3.3k
G
R986
0
5
S[4]
S[3]
COM[4]
COM[3]
COM[2]
COM[1]
S[2]
Q902
2SC3052EF-T1-LEF
BACK LIGHT
LED DRIVE
R926
2.2k
*5 R940,948,952
180 (GT35U)
150 (GT39U/GT39UE)
*7 R944,959,964,968
100 (GT35U)
68 (GT39U/GT39UE)
R911
1.2k
0.8
S902
AUX_LCH
2
R963
*6
*2 R935
180 (GT35U)
100 (GT39U/GT39UE)
*4 R939,947,951
220 (GT35U)
150 (GT39U/GT39UE)
0.2
R931
1.2k
R904
1M
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
1
1
4
*1 LED907,911,913-915,
918,924,925,930,931
SML-310VTT86TJ (GT35U)
SML-310PTT86TK (GT39U/GT39UE)
W004
CE
CLK
DATA
2
3
IC902
RS-470
REMOTE CONTROL
SIGNAL RECEIVER
1
2
VCC GND1
3
4
OUT GND2
R998
0
1
R923
1.2k
S908
W001
R910
180
3
6
FB902
CDX-GT35U/GT39U/GT39UE
R928
820
1
4
5.2
5.1
C906
0.1
R930
1k
1
2
FB901
I
LED901
NESW505CT-AST
(LCD BACK LIGHT)
R929
1k
6
JACK BOARD
H
3
6
4
3
J901
AUX
R921
1k
S906
SOURCE
L901
F
2
R959
*7
D
(USB)
4
CLK
DATA
RB901
10X2
E
6
IC902
R906
150
R955
*6
CE
VDR900
CN902
1
VDR906
VDR901
CN902
4P
3
BACK-LIGHT
R920
820
5
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
LSW901
AUX_LCH
AUX_RCH
LSW905
DSPL/SCRL
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
1
5.1
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
2.6
PANEL_SW(NOSE_SW)
3
R905
100
S[48]
S[47]
S[46]
S[45]
S[44]
S[43]
S[42]
S[41]
S[40]
S[39]
S[38]
S[37]
C
5
R907
150
DIMMER
COLOR
BLINK
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
SEG39
SEG38
SEG37
(Page 21)
R935
*2
5.1
5.1
A
D911
MAZ8068GMLS0
D912
MAZ8068GMLS0
D901
1SS355WTE-17
MAIN
BOARD
(3/3)
CN403
CN901
20P
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
D902
MAZ8051GMLS0
B
GND
USB_VBUS
GND
USB_GND
KEY_GND
USB_D+
AUX_LCH
USB_DKEY1
AUX_RCH
RE1
AUX_GND
RE0
KEY0
LCD_CE
SIRCS
LCD_CLK
LCD_DATA
ILL_+10.4V
S[1]
S[2]
S[3]
S[4]
S[5]
S[6]
S[7]
S[8]
S[9]
S[10]
S[11]
S[12]
S[13]
S[14]
S[15]
S[16]
S[17]
S[18]
S[19]
S[20]
S[21]
S[22]
S[23]
S[24]
S[25]
S[26]
S[27]
S[28]
S[29]
S[30]
S[31]
S[32]
S[33]
S[34]
S[35]
S[36]
S[37]
S[38]
S[39]
S[40]
S[41]
S[42]
S[43]
S[44]
S[45]
S[46]
S[47]
S[48]
COM[4]
COM[3]
COM[2]
COM[1]
A
23
LCD901
LIQUID CRYSTAL DISPLAY PANEL
8
7
6
5
4
3
2 1
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
• IC Block Diagrams
2 SDA
OUT-FL– 3
VOUT
TAB 1
IC402 TK11133CSCL-G (MAIN Board (1/3))
VIN
IC301 TDA8588AJ/N2/R1 (MAIN Board (1/3)) (E, Argentina model)
IC301 TDA8589AJ/N2/R1 (MAIN Board (1/3)) (Russian model)
IC301 TDA8589AJ/N2/R1/M5 (MAIN Board (1/3)) (AEP, UK model)
5
4
IC501 TPS40200DRG4 (MAIN Board (2/3))
2
I C BUS
UVLO
4 SCL
FL
8 VCC
OVERHEAT &
OVERCURRENT
PROTECTION
OUT-FL+ 5
6 VP2
OSC
RC 1
7 ISNS
CONTROL
CIRCUIT
OUT-RL– 7
RL
PWM
LOGIC
8 P-GND1
OUT-RL+ 9
12 IN-FL
RR
18 P-GND3
1
2
700mV
COMP 3
3
ENABLE E/A
NOISE
16 BEEP
VP
5 GND
SOFT-START
AND
OVERCURRENT
14 IN-FR
OUT-RR+ 17
OUT-RR– 19
FB 4
20 VP1
OUT-FR+ 21
FR
OUT-FR– 23
STANDBY/
MUTE
22 STB
CHIP DETECT/
DIAGNOSTIC
24 P-GND4
BATTERY
DETECTION
DIAG 25
TEMPERATURE
PROTECTION
ENABLE
LOGIC
IC503 NJM2387ADL3 (TE2) (MAIN Board (2/3))
IC001 TEF6617/V1/S470, 518 (MAIN Board (3/3)) (E, Russian, Argentina model)
IC001 TEF6617/V1/S470/M5, 518 (MAIN Board (3/3)) (AEP, UK model)
26 RST
ANT-REM 27
SWITCH
CURRENT
LIMIT
28 CRES
AMP-REM 29
AMRFIN 1
30 AUDIO+B
REGULATOR
SERVO+3.3V 31
MECH+6V 33
FMIN2 3
32 GND
OVERVOLTAGE
PROTECTION
FMIN1 4
THERMAL
PROTECTION
REGULATOR
29 AMSELIN2
28 AMSELIN1
27 TEST
RDS
DEMODULATOR
AND
DECODER
36 CBU
LOADDUMP
PROTECTION
30 AMIFAGC1
FM
TUNER
VCC2 6
BAND GAP
REFERENCE
REFERENCE
VOLTAGE
31 AMSELOUT1
GNDRF 5
34 PANEL+B
VP 35
BU+B 37
32 AMSELOUT2
AM
TUNER
AMRFDEC 2
SWITCH
BACK-UP
SWITCH
AMRFAGC 7
LOUT 8
ROUT 9
1
2
3
4
5
VIN
CONT
VOUT
VADJ
GND
GNDAUD 10
OUTPUT
STEREO DECODER
HIGH CUT
SOFT MUTE
NOISE BLANKER
AMIFAGC2 11
MPXIN 12
MPXOUT 13
RSSI 14
XTAL2 15
XTAL1 16
CDX-GT35U/GT39U/GT39UE
24
24
6 DRV
E/A AND SS
REFERENCE
SS 2
GND
IN-RR 15
BAND GAP
REFERENCE
CONT
PROTECTION/
DIAGNOSTIC
MUTE
S-GND 13
10 SVR
MUTE
IN-RL 11
DRIVER
26 PLLREF
PLL
TUNING
SYSTEM
25 PLL
24 VCODEC
23 GND
POWER
SUPPLY
SIGNAL
IMPROVEMENT
CONTROL
BANDWIDTH
CONTROL
22 VCC1
21 VREGSUP
20 VREF
19 SDA
I2C BUS
18 SCL
17 GNDD
CDX-GT35U/GT39U/GT39UE
OPEN
A-GND
I2C_SIO
I2C_SCK
VCC
O/P FL
O/P FR
O/P RL
O/P RR
O/P SUB L
O/P SUB R
OPEN
PULL UP
OPEN
IC804 BD3705FV-E2 (MAIN Board (3/3))
28
27
26
25
24
23
22
21
20
19
18
17
16
15
I2C BUS
LOGIC
VCC
FADER
FADER
FADER
FADER
FADER
LPF
LOUDNESS
3 BAND P-EQ(TONE CONTROL)
VOLUME/MUTE
LEVEL METER
(I2C)
INPUT GAIN
INPUT SELECTOR (2 SIGNAL END 2 STEREO (SO))
GND
ISO AMP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
TO_RCH
CD_LCH
CD_RCH
AUX_LCH
AUX_GND
AUX_RCH
OPEN
OPEN
ZAP BEEP L
ZAP BEEP R
OPEN
GND
ISO AMP
TO_LCH
GND
ISO AMP
FIL C
GND
ISO AMP
OPEN
VCC2
25
CDX-GT35U/GT39U/GT39UE
• IC Pin Function Description
MAIN BOARD (2/3) IC401 MB90F882PF-G-103E1 (SYSTEM CONTROL)
Pin No.
Pin Name
I/O
Description
1
CYRIL_SEL
I
2
B-OUT_SEL
I
Black out setting signal input (L: No black out)
3
COL_SW_SEL
I
Key illumination initial color setting signal input (L: Amber)
Cyril select signal input (L: No cyril select)
4
ILLUMI_SEL
I
Key illumination voltage setting signal input (H: 10.4 V)
5, 6
NCO
O
Not used. (Open)
Front panel detach detect signal input
7
NOSE_SW
I
8 to 10
NCO
O
Not used. (Open)
11
RE_IN0
I
Rotary encoder signal input 0
12
RE_IN1
I
Rotary encoder signal input 1
13
X_OUT
O
Low speed operation clock signal output (32.768 kHz)
14
X_IN
I
Low speed operation clock signal input (32.768 kHz)
15
VCC
―
Power supply pin (+3.3 V)
16
VSS
―
Ground
17
C
―
18
UNISI
I
SONY-BUS data input Not used.
19
UNISO
O
SONY-BUS data output Not used. (Open)
Regulator reference capacitor connecting pin
20
UNISCK
O
SONY-BUS clock signal output Not used. (Open)
21
USB_ON
O
USB over current detect IC control signal output
22
I2C_SIO
I/O
I2C serial data input/output
23
I2C_SCK
O
I2C serial clock signal output
24
USB_OVER
I
USB over current detect signal input
25
BUS_ON
O
BUS ON signal output Not used. (Fixed at L is this set.)
26
SYS_RST
O
System reset signal output
27
CD_ON
I
CD mechanism servo power supply control request signal input
28
CDM_ON
I
CD mechanism deck power supply control request signal input
29
ACC_IN
I
Accessory power supply detect signal input
30
TEL_ATT
I
Telephone attenuator detect signal input (Except E model)
31
ATT
O
Audio mute control signal output
32
AVCC
―
A/D converter power supply pin (+3.3 V)
33
AVRH
―
34
RC_IN1
I
35
AVSS
―
36
QUALITY
I
Not used. (Open)
37
VSM
I
S meter voltage detect signal input
38
SA_IN
I
Spectrum analyzer DC input Not used. (Open)
39
KEY_IN1
I
Key signal input 1
40
KEY_IN0
I
Key signal input 0
A/D converter external reference power supply pin (+3.3 V)
Rotary commander shift key signal input 1
Ground for A/D converter
41
RC_IN0
I
Rotary commander shift key signal input 0
42, 43
NCO
O
Not used. (Open)
44
VSS
―
45
KEY_ACK0
I
Key acknowledge detect signal input (Rotary commander)
46
KEY_ACK1
I
Key acknowledge detect signal input (Front panel)
47
EXTATT_XEN
O
L is sent when electronic volume IC has the status of CD/USB (H is sent when it has the
status of other source)
26
Ground
48
LCD_CE
O
LCD driver chip enable signal output
49
LCD_SO
O
LCD driver serial data output
50
LCD_SCK
O
LCD driver serial clock signal output
51
MD2
I
Micon operation mode setting signal input (active: L)
52
MD1
I
Micon operation mode setting signal input (Fixed at H in this set)
53
MD0
I
Micon operation mode setting signal input (active: H)
54
RESET
I
Reset signal input
55
AREA_SEL2
I
Destination setting pin 2 (Fixed at L in except E model, Frequency select switch signal input in
E model)
56
AREA_SEL1
I
Destination setting pin 1 (L: Except Russian model, H: Russian model)
CDX-GT35U/GT39U/GT39UE
Pin No.
Pin Name
I/O
57
AREA_SEL0
I
Description
58
WAKE_UP
O
CD mechanism deck micon wake up signal output
59
MC_RX
I
MC-BUS communication and CD mechanism deck micon communication RX input
60
MC_TX
O
MC-BUS communication and CD mechanism deck micon communication TX output
Destination setting pin 0 (L: E model, H: Except E model)
61
CLK_IN
I
Flash programming serial clock signal input
62
Z_MUTE
I
Z mute signal input
63
NCO
O
Not used. (Open)
64
TEST
O
Not used. (Open)
65
VCC
―
Power supply pin (+3.3 V)
66
VSS
―
Ground
67
NCO
O
Not used. (Open)
68
AMP_STB
O
Standby signal output for power regulator IC
69
DIAG
I
Condition signal input from power amp IC
70
VBUS_ON
I
VBUS power supply control signal input (L: VBUS OFF, H: VBUS ON)
71
SA_OUT
O
Spectrum analyzer serial data output
72
SA_CLK
O
Spectrum analyzer serial clock signal output
73
NCO
O
Not used. (Open)
74
TU_ATT
O
Tuner mute control signal output (Not used in this set)
75
NSMASK
O
Not used. (Open)
76
RDS_ON
O
RDS IC power supply control signal output Not used. (Open)
77
FLASH_EN0
I
Flash writer programming wake up signal input (Fixed at L)
78
FLASH_EN1
I
Flash writer programming wake up signal input
79 to 81
NCO
O
Not used. (Open)
82
TU_ATTIN
O
Not used. (Open)
83
BU_CHECK
I
Back up power supply detect signal input
84
EQ TYPE_SEL
I
EQ type select signal input (Fixed at L)
85 to 89
NCO
O
Not used. (Open)
90
VCC
―
Power supply pin (+3.3 V)
91
VSS
―
Ground
92
OSC_OUT
O
High speed operation clock signal output (7.92 MHz)
93
OSC_IN
I
High speed operation clock signal input (7.92 MHz)
94
NCO
O
Not used. (Open)
95
SIRCS
I
Remote control signal input
96
NCO
O
Not used. (Open)
97
BEEP
O
Beep signal output for power amplifier IC
98
ZAPPIN
O
Zappin beep signal output
99
SYNC_OUT
O
DC/DC converter oscillation frequency control signal output
100
DD_ON
O
DC/DC converter power supply ON/OFF control signal output
27
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
SECTION 5
EXPLODED VIEWS
Note:
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
5-1.
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of the
electrical parts list.
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
• Abbreviation
RU
: Russian model
AR
: Argentina model
MAIN SECTION
not supplied
A
MG-101Y-188//Q
#2
6
#1
#3
B
A
#5
FU601
#4
#5
4
#3
#4
not supplied
5
not supplied
3
#1
not supplied
B
2
#1
not supplied
#1
not supplied
1
front panel section
Ref. No.
Part No.
Description
1
2
3
4
5
X-2320-690-3
3-042-244-11
X-2179-399-1
2-050-124-02
A-1738-025-A
PANEL ASSY, SUB
SCREW (T)
LOCK ASSY (S)
SCREW +BTT 2.6X5
MAIN BOARD, COMPLETE (AEP,UK)
5
5
5
6
6
A-1738-283-A
A-1738-284-A
A-1738-285-A
1-776-527-11
1-831-838-11
MAIN BOARD, COMPLETE (GT35U:RU)
MAIN BOARD, COMPLETE (GT39UE)
MAIN BOARD, COMPLETE (E,AR)
CORD (WITH CONNECTOR) (ISO) (POWER) (AR)
CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK,RU)
28
Remark
Ref. No.
Part No.
Description
6
1-833-974-11
FU601
#1
#2
#3
1-532-877-11
7-685-792-09
7-685-790-01
7-685-793-09
CONNECTION CORD FOR AUTOMOBILE
(POWER) (E)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X4 (S)
SCREW +PTT 2.6X8 (S)
Remark
#4
#5
7-685-794-09
7-685-134-19
SCREW +PTT 2.6X10 (S)
SCREW +P 2.6X8 TYPE2 NON-SLIT
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
5-2.
FRONT PANEL SECTION
58
59
57
not supplied
(KEY board)
58
RE901
not supplied
56
not supplied
(JACK board)
55
not supplied
54
CN902
LCD901
not supplied
not supplied
not supplied
not supplied
not supplied
51
53
52
Ref. No.
Part No.
Description
Remark
51
51
52
52
52
X-2320-608-1
X-2342-501-1
X-2514-658-1
X-2514-736-1
X-2514-737-1
BUTTON ASSY (S) (AEP,UK,RU)
BUTTON ASSY (S) (E,AR)
PANEL (SV) ASSY, FRONT (GT35U:AEP,UK,RU)
PANEL (SV) ASSY, FRONT (GT39U)
PANEL (SV) ASSY, FRONT (GT39UE)
52
53
54
55
56
X-2514-738-1
X-2319-728-1
2-639-881-01
1-780-659-21
4-157-873-02
PANEL (SV) ASSY, FRONT (GT35U:E,AR)
KNOB (VOL) (SV) ASSY
SPRING (RELEASE)
CONNECTOR (RUBBER)
ILLUMINATOR (LCD)
57
3-876-858-02
PANEL, BACK
Ref. No.
Part No.
Description
Remark
58
59
3-250-543-21
A-1737-741-A
59
59
59
A-1738-294-A
A-1738-295-A
A-1738-296-A
SCREW (+B P-TITE M2)
PANEL COMPLETE ASSY, FRONT
(GT35U:AEP,UK,RU)
PANEL COMPLETE ASSY, FRONT (GT39U)
PANEL COMPLETE ASSY, FRONT (GT39UE)
PANEL COMPLETE ASSY, FRONT (GT35U:E,AR)
CN902
LCD901
RE901
1-820-858-21
1-802-991-11
1-479-902-32
CONNECTOR, USB (SOCKET) 4P (USB)
DISPLAY PANEL, LIQUID CRYSTAL
ENCODER, ROTARY
(PUSH ENTER/SELECT,VOLUME)
29
CDX-GT35U/GT39U/GT39UE
5-3.
CD MECHANISM SECTION
(MG-101Y-188//Q)
101
102
not supplied
108
103
not supplied
108
105
not supplied
not supplied
not supplied
not supplied
not supplied
104
not supplied
not supplied
not supplied
not supplied
107
not supplied
Ref. No.
101
102
0 103
104
30
106
106
Part No.
Description
A-1313-179-A
A-1284-705-A
X-2149-672-1
2-626-869-31
MECHANICAL BLOCK (U) ASSY (08)
DAXEV08//Q
SERVICE ASSY, OP (DAX-25A)
SCREW (M2X3), SERRATION
Remark
Ref. No.
105
106
107
108
Part No.
Description
3-686-458-21
3-352-758-31
A-1555-002-A
2-134-636-71
SCREW (P1.4), TAPPING
SCREW (M1.7X2.5), TOOTHED LOCK
SERVO BOARD, COMPLETE
SCREW (M1.7X2.5)
Remark
CDX-GT35U/GT39U/GT39UE
SECTION 6
ELECTRICAL PARTS LIST
Note:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• CAPACITORS
uF: μF
Ref. No.
Part No.
• COILS
uH: μH
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• SEMICONDUCTORS
In each case, u: μ, for example:
uA. . : μA. . , uPA. . , μPA. . ,
uPB. . : μPB. . , uPC. . , μPC. . ,
uPD. . : μPD. .
Description
Remark
Ref. No.
Part No.
JACK BOARD
**********
JACK
Ver. 1.1
KEY
When indicating parts by reference number, please include the board name.
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
• Abbreviation
RU
: Russian model
AR
: Argentina model
Description
Remark
< LIQUID CRYSTAL DISPLAY >
LCD901
1-802-991-11
DISPLAY PANEL, LIQUID CRYSTAL
< FERRITE BEAD >
< DIODE >
FB901
FB902
FB903
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
LED901
LED907
LED907
LED911
6-501-339-01
6-502-875-01
6-502-877-01
6-502-875-01
LED911
6-502-877-01
LED913
6-502-875-01
LED913
LED914
6-502-877-01
6-502-875-01
CONNECTOR (RUBBER)
ILLUMINATOR (LCD)
LED914
6-502-877-01
< CAPACITOR >
LED915
6-502-875-01
LED915
LED918
6-502-877-01
6-502-875-01
LED918
LED924
6-502-877-01
6-502-875-01
< CONNECTOR >
LED924
6-502-877-01
LED SML-310VTT86TJ ( ) (GT35U)
LED SML-310PTT86TK (MODE)
(GT39U/GT39UE)
LED SML-310VTT86TJ (MODE) (GT35U)
LED SML-310PTT86TK (MODE)
(GT39U/GT39UE)
LED SML-310VTT86TJ (MODE) (GT35U)
PLUG, CONNECTOR 20P
CONNECTOR, USB (SOCKET) 4P (USB)
LED925
LED925
LED930
LED930
LED931
6-502-875-01
6-502-877-01
6-502-875-01
6-502-877-01
6-502-875-01
LED
LED
LED
LED
LED
LED931
6-502-877-01
LED SML-310VTT86TJ (m . SEEK–)
(GT35U)
< JACK >
J901
1-819-732-11 JACK (DIA. 3.5) (AUX)
*************************************************************
KEY BOARD
*********
1-780-659-21
4-157-873-02
C901
C902
C903
C904
C906
CN901
CN902
1-107-826-11
1-107-826-11
1-107-826-11
1-125-891-11
1-107-826-11
1-820-619-11
1-820-858-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.47uF
0.1uF
10%
10%
10%
10%
10%
< DIODE >
D901
D902
D906
D907
D908
6-501-193-01
6-501-730-01
6-501-782-01
6-501-743-01
6-501-743-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
MAZ8051GMLS0
MAZ8180GMLS0
MAZ8068GMLS0
MAZ8068GMLS0
D909
D910
D911
D912
6-501-743-01
6-501-743-01
6-501-743-01
6-501-743-01
DIODE
DIODE
DIODE
DIODE
MAZ8068GMLS0
MAZ8068GMLS0
MAZ8068GMLS0
MAZ8068GMLS0
16V
16V
16V
10V
16V
LED
LED
LED
LED
NESW505CT-AST (LCD BACK LIGHT)
SML-310PTT86TK (OFF) (GT39U/GT39UE)
SML-310VTT86TJ (OFF) (GT35U)
SML-310PTT86TK (SOURCE)
(GT39U/GT39UE)
LED SML-310VTT86TJ (SOURCE) (GT35U)
LED SML-310PTT86TK (SOURCE)
(GT39U/GT39UE)
LED SML-310VTT86TJ (SOURCE) (GT35U)
LED SML-310PTT86TK (SEEK+ > M)
(GT39U/GT39UE)
LED SML-310VTT86TJ (SEEK+ > M)
(GT35U)
LED SML-310PTT86TK ( ) (GT39U/GT39UE)
SML-310PTT86TK ( ) (GT39U/GT39UE)
SML-310VTT86TJ ( ) (GT35U)
SML-310PTT86TK ( ) (GT39U/GT39UE)
SML-310VTT86TJ ( ) (GT35U)
SML-310PTT86TK (m . SEEK–)
(GT39U/GT39UE)
< SWITCH >
LSW901 1-786-805-13
LSW901 1-786-806-13
LSW905 1-786-805-13
< IC >
LSW905 1-786-806-13
IC901
IC902
6-714-396-01
6-600-629-01
IC LC75829PWH-US-H
IC RS-470 (IR)
LSW906 1-786-805-13
SWITCH, TACTILE (WITH LED) (Z) (GT35U)
SWITCH, TACTILE (WITH LED) (Z)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (DSPL/SCRL)
(GT35U)
SWITCH, TACTILE (WITH LED) (DSPL/SCRL)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (6/PAUSE)
(GT35U)
< COIL >
LSW906 1-786-806-13
L901
1-457-223-11
COIL, COMMON MODE CHOKE
SWITCH, TACTILE (WITH LED) (6/PAUSE)
(GT39U/GT39UE)
31
CDX-GT35U/GT39U/GT39UE
KEY
Ref. No.
Part No.
LSW907 1-786-805-13
LSW907 1-786-806-13
LSW908 1-786-805-13
LSW908 1-786-806-13
LSW909 1-786-805-13
LSW909 1-786-806-13
LSW910 1-786-805-13
LSW910 1-786-806-13
LSW911 1-786-805-13
LSW911 1-786-806-13
LSW912 1-786-805-13
LSW912 1-786-805-13
LSW912 1-786-806-13
LSW913 1-786-805-13
LSW913 1-786-806-13
Q901
Q902
Q907
8-729-620-07
8-729-620-07
8-729-620-07
Description
Remark
Part No.
Description
R935
1-216-812-11
METAL CHIP
180
R936
1-216-029-00
METAL CHIP
150
R936
1-216-031-00
METAL CHIP
180
R939
1-216-029-00
METAL CHIP
150
R939
1-216-033-00
METAL CHIP
220
R940
1-216-029-00
METAL CHIP
150
R940
1-216-031-00
METAL CHIP
180
R943
1-216-022-00
METAL CHIP
75
R943
1-216-025-11
METAL CHIP
100
R944
1-216-021-00
METAL CHIP
68
R944
1-216-025-11
METAL CHIP
100
R947
1-216-029-00
METAL CHIP
150
R947
1-216-033-00
METAL CHIP
220
R948
1-216-029-00
METAL CHIP
150
SWITCH, TACTILE (WITH LED) (ZAP)
(GT39U/GT39UE)
R948
1-216-031-00
METAL CHIP
180
< TRANSISTOR >
R951
1-216-029-00
METAL CHIP
150
TRANSISTOR 2SC3052EF-T1-LEF
TRANSISTOR 2SC3052EF-T1-LEF
TRANSISTOR 2SC3052EF-T1-LEF
R951
1-216-033-00
METAL CHIP
220
R952
1-216-029-00
METAL CHIP
150
< RESISTOR >
R952
1-216-031-00
METAL CHIP
180
R955
1-216-809-11
METAL CHIP
100
R955
1-218-285-11
METAL CHIP
75
R959
1-216-807-11
METAL CHIP
68
R959
1-216-809-11
METAL CHIP
100
R963
1-216-809-11
METAL CHIP
100
R963
1-218-285-11
METAL CHIP
75
R964
1-216-807-11
METAL CHIP
68
R964
1-216-809-11
METAL CHIP
100
R967
1-216-809-11
METAL CHIP
100
R967
1-218-285-11
METAL CHIP
75
R968
1-216-021-00
METAL CHIP
68
R968
1-216-025-11
METAL CHIP
100
5%
1/10W
(GT35U)
R986
R987
R988
R989
1-216-864-11
1-216-864-11
1-216-809-11
1-216-809-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
100
100
5%
5%
1/10W
1/10W
SWITCH, TACTILE (WITH LED) (5/DM+)
(GT35U)
SWITCH, TACTILE (WITH LED) (5/DM+)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (4/SHUF)
(GT35U)
SWITCH, TACTILE (WITH LED) (4/SHUF)
(GT39U/GT39UE)
Remark
SWITCH, TACTILE (WITH LED) (3/REP)
(GT35U)
SWITCH, TACTILE (WITH LED) (3/REP)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (2/ALBM +)
(GT35U)
SWITCH, TACTILE (WITH LED) (2/ALBM +)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (1/ALBM -)
(GT35U)
SWITCH, TACTILE (WITH LED) (1/ALBM -)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (AF/TA/PTY)
(GT35U:AEP,UK,RU)
SWITCH, TACTILE (WITH LED) (BTM)
(GT35U:E)
SWITCH, TACTILE (WITH LED) (AF/TA/PTY)
(GT39U/GT39UE)
SWITCH, TACTILE (WITH LED) (ZAP) (GT35U)
R904
R905
R906
R907
R908
1-216-857-11
1-216-809-11
1-216-811-11
1-216-811-11
1-216-812-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
100
150
150
180
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R909
R910
R911
R914
R920
1-216-812-11
1-216-812-11
1-216-822-11
1-216-864-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
180
180
1.2K
0
820
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R921
R922
R923
R924
R925
1-216-821-11
1-216-821-11
1-216-822-11
1-216-823-11
1-216-824-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1.2K
1.5K
1.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R926
R927
R928
R929
R930
1-216-825-11
1-216-827-11
1-216-820-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
820
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R931
R932
R933
R934
R935
1-216-822-11
1-216-823-11
1-216-824-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
1.5K
1.8K
2.2K
100
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(GT39U/GT39UE)
32
Ref. No.
5%
1/10W
(GT35U)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT35U)
5%
1/10W
(GT35U)
5%
1/10W
(GT39U/GT39UE)
5%
1/10W
(GT39U/GT39UE)
CDX-GT35U/GT39U/GT39UE
KEY
Ref. No.
Part No.
Description
R990
R991
R992
R993
R996
1-216-809-11
1-216-827-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
3.3K
10K
10K
10K
Remark
R998
1-216-864-11
SHORT CHIP
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< NETWORK RESISTOR >
RB901
1-239-662-81
RESISTOR, NETWORK 10X2
< ROTARY ENCODER >
RE901
1-479-902-32
ENCODER, ROTARY
(PUSH ENTER/SELECT,VOLUME)
Ref. No.
Ver. 1.1
MAIN
Part No.
Description
C101
C103
C104
C105
C106
1-164-739-11
1-126-961-11
1-163-251-11
1-126-960-11
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
560PF
2.2uF
100PF
1uF
10uF
5%
20%
5%
20%
20%
50V
50V
50V
50V
50V
Remark
C107
C108
C109
C110
C111
1-163-251-11
1-126-964-11
1-165-908-11
1-165-908-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
10uF
1uF
1uF
100PF
5%
20%
10%
10%
5%
50V
50V
10V
10V
50V
C112
C113
C114
C115
C116
1-126-964-11
1-163-251-11
1-165-908-11
1-165-908-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
100PF
1uF
1uF
100PF
20%
5%
10%
10%
5%
50V
50V
10V
10V
50V
C201
C203
C204
C205
C206
1-164-739-11
1-126-961-11
1-163-251-11
1-126-960-11
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
560PF
2.2uF
100PF
1uF
10uF
5%
20%
5%
20%
20%
50V
50V
50V
50V
50V
C207
C208
C209
C210
C211
1-163-251-11
1-126-964-11
1-165-908-11
1-165-908-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
10uF
1uF
1uF
100PF
5%
20%
10%
10%
5%
50V
50V
10V
10V
50V
C212
C213
C214
C215
C216
1-126-964-11
1-163-251-11
1-165-908-11
1-165-908-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
100PF
1uF
1uF
100PF
20%
5%
10%
10%
5%
50V
50V
10V
10V
50V
C217
C301
C302
C303
C304
1-126-964-11
1-162-964-11
1-162-923-11
1-128-551-11
1-115-340-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
10uF
0.001uF
47PF
22uF
0.22uF
20%
10%
5%
20%
10%
50V
50V
50V
63V
25V
C305
C306
C307
C308
C309
1-115-340-11
1-165-908-11
1-124-589-11
1-162-970-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.22uF
1uF
47uF
0.01uF
10uF
10%
10%
20%
10%
20%
25V
10V
16V
25V
16V
< SWITCH >
S902
S903
S904
S905
S906
1-786-653-21
1-786-653-21
1-786-653-21
1-786-653-21
1-786-653-21
SWITCH, TACTILE (m . SEEK–)
SWITCH, TACTILE ( )
SWITCH, TACTILE (MODE)
SWITCH, TACTILE (SEEK+ > M)
SWITCH, TACTILE (SOURCE)
S907
S908
1-786-653-21
1-786-653-21
SWITCH, TACTILE (OFF)
SWITCH, TACTILE ( )
< VARISTOR >
VDR900 1-804-988-21 VARISTOR, CHIP (1608)
VDR901 1-804-988-21 VARISTOR, CHIP (1608)
VDR903 1-804-988-21 VARISTOR, CHIP (1608)
VDR906 1-804-988-21 VARISTOR, CHIP (1608)
VDR908 1-804-988-21 VARISTOR, CHIP (1608)
*************************************************************
A-1738-025-A
A-1738-283-A
A-1738-284-A
A-1738-285-A
MAIN BOARD, COMPLETE (AEP,UK)
MAIN BOARD, COMPLETE (GT35U:RU)
MAIN BOARD, COMPLETE (GT39UE)
MAIN BOARD, COMPLETE (E,AR)
********************
7-685-134-19
7-685-794-09
SCREW +P 2.6X8 TYPE2 NON-SLIT
SCREW +PTT 2.6X10 (S)
< CAPACITOR >
C1
C5
C6
C8
C9
1-162-964-11
1-162-964-11
1-162-917-11
1-162-921-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
15PF
33PF
0.1uF
10%
10%
5%
5%
10%
50V
50V
50V
50V
16V
C311
C312
C313
C314
C315
1-162-970-11
1-124-233-11
1-124-233-11
1-162-923-11
1-125-889-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
10uF
10uF
47PF
2.2uF
10%
20%
20%
5%
10%
25V
16V
16V
50V
10V
C12
C13
C16
C17
C18
1-127-715-11
1-100-742-91
1-125-891-11
1-107-826-11
1-162-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
2.2uF
0.47uF
0.1uF
12PF
10%
20%
10%
10%
5%
16V
10V
10V
16V
50V
C316
C317
C318
C319
C322
1-107-826-11
1-126-934-11
1-165-908-11
1-126-964-11
1-126-947-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0.1uF
220uF
1uF
10uF
47uF
10%
20%
10%
20%
20%
16V
16V
10V
50V
35V
C19
C20
C21
C22
C23
1-162-970-11
1-162-970-11
1-165-908-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
10V
25V
25V
C323
C401
C402
C403
C404
1-126-961-11
1-162-970-11
1-107-826-11
1-128-057-11
1-115-340-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
2.2uF
0.01uF
0.1uF
330uF
0.22uF
20%
10%
10%
20%
10%
50V
25V
16V
6.3V
25V
C24
C25
C26
C27
C28
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-126-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.1uF
47uF
10%
10%
10%
10%
20%
16V
16V
16V
16V
35V
C405
C406
C407
C409
C411
1-115-340-11
1-162-970-11
1-162-970-11
1-126-926-11
1-126-924-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.22uF
0.01uF
0.01uF
1000uF
330uF
10%
10%
10%
20%
20%
25V
25V
25V
10V
10V
33
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
MAIN
Ref. No.
Part No.
Description
C413
C416
C417
C418
C419
1-162-964-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-920-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.01uF
0.01uF
0.01uF
27PF
10%
10%
10%
10%
5%
50V
25V
25V
25V
50V
Remark
C420
C421
C422
C423
C424
1-162-921-11
1-162-970-11
1-165-908-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33PF
0.01uF
1uF
0.01uF
0.01uF
5%
10%
10%
10%
10%
50V
25V
10V
25V
25V
C425
C426
C427
C428
C429
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
25V
C433
C434
C435
C436
C501
1-124-589-11
1-162-970-11
1-107-826-11
1-162-970-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.01uF
0.1uF
0.01uF
0.1uF
20%
10%
10%
10%
10%
16V
25V
16V
25V
16V
C502
C503
C504
C505
C506
1-165-727-31
1-100-352-91
1-107-826-11
1-164-315-11
1-164-315-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
120uF
1uF
0.1uF
470PF
470PF
20%
20%
10%
5%
5%
16V
16V
16V
50V
50V
C507
C508
C509
C513
C514
1-100-352-91
1-162-965-11
1-162-917-11
1-107-826-11
1-126-924-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.0015uF
15PF
0.1uF
330uF
20%
10%
5%
10%
20%
16V
50V
50V
16V
10V
C516
C518
C519
C520
C521
1-107-826-11
1-126-934-11
1-165-908-11
1-124-584-00
1-164-315-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
220uF
1uF
100uF
470PF
10%
20%
10%
20%
5%
16V
16V
10V
10V
50V
C523
C524
C701
C702
C703
1-104-665-11
1-107-826-11
1-124-584-00
1-124-234-00
1-124-233-11
ELECT
CERAMIC CHIP
ELECT
ELECT
ELECT
100uF
0.1uF
100uF
22uF
10uF
20%
10%
20%
20%
20%
25V
16V
10V
16V
16V
C704
C705
C706
C707
C803
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-100-385-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.47uF
10%
10%
10%
10%
25V
25V
25V
25V
25V
C804
C805
C806
C807
C808
1-100-385-91
1-163-009-91
1-163-009-91
1-112-302-11
1-115-340-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.47uF
0.001uF
0.001uF
3300uF
0.22uF
10%
10%
20%
10%
25V
50V
50V
16V
25V
C810
C811
C812
C813
C815
1-115-340-11
1-115-340-11
1-165-908-11
1-165-908-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.22uF
1uF
1uF
0.001uF
10%
10%
10%
10%
10%
25V
25V
10V
10V
50V
< CONNECTOR >
* CN401
CN403
CN501
CN701
34
1-564-710-11
1-820-622-21
1-564-705-11
1-820-611-11
PIN, CONNECTOR (SMALL TYPE) 8P
SOCKET, CONNECTOR 20P
PIN, CONNECTOR (SMALL TYPE) 3P
CONNECTOR, BOARD TO BOARD 28P
Ref. No.
CN802
Part No.
Description
1-774-701-21
PIN, CONNECTOR 16P
Remark
< DIODE >
D101
D104
D105
D201
D204
1-805-043-11
6-502-643-01
6-502-643-01
1-805-043-11
6-502-643-01
ABSORBER, CHIP SURGE
DIODE 1A4-A2
DIODE 1A4-A2
ABSORBER, CHIP SURGE
DIODE 1A4-A2
D205
D301
D302
D303
D304
6-502-643-01
8-719-978-33
6-502-643-01
6-502-643-01
6-502-643-01
DIODE
DIODE
DIODE
DIODE
DIODE
1A4-A2
DTZ-TT11-6.8B
1A4-A2
1A4-A2
1A4-A2
D305
D306
D308
D309
D401
6-502-643-01
6-501-817-01
6-501-817-01
6-501-817-01
6-502-131-01
DIODE
DIODE
DIODE
DIODE
DIODE
1A4-A2
MA2J1110GLS0
MA2J1110GLS0
MA2J1110GLS0
LRB751V-40T1G
D403
D404
D410
D411
D502
6-501-743-01
6-501-743-01
6-501-743-01
1-107-826-11
6-501-817-01
DIODE MAZ8068GMLS0
DIODE MAZ8068GMLS0
DIODE MAZ8068GMLS0
CERAMIC CHIP 0.1uF
DIODE MA2J1110GLS0
D503
D504
D505
D510
D511
6-501-768-01
6-501-657-01
6-501-734-01
6-501-718-01
6-501-817-01
DIODE
DIODE
DIODE
DIODE
DIODE
MAZ8120GMLS0
MA24D5000BS0
MAZ8056GMLS0
MAZ8039GLLS0
MA2J1110GLS0
D512
D701
D806
D807
D808
6-501-817-01
6-501-656-01
6-501-747-01
6-501-782-01
6-501-782-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA2J1110GLS0
LBAT54ALT1G
MAZ8075GMLS0
MAZ8180GMLS0
MAZ8180GMLS0 (AEP,UK,RU)
D809
D810
D811
D812
D813
6-501-782-01
6-501-782-01
6-501-782-01
6-501-571-01
6-502-643-01
DIODE
DIODE
DIODE
DIODE
DIODE
MAZ8180GMLS0
MAZ8180GMLS0
MAZ8180GMLS0
1N5404-C311-3
1A4-A2 (AEP,UK)
10%
16V
< FUSE >
F501
1-576-416-21
FUSE, MICRO (1608 TYPE) 2A
< FERRITE BEAD >
FB101
FB201
FB301
FB701
FB702
1-400-334-21
1-400-334-21
1-469-876-11
1-469-844-11
1-414-595-11
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
INDUCTOR, FERRITE BEAD
INDUCTOR
2.2uH
INDUCTOR, FERRITE BEAD
FB705
FB707
1-414-228-11
1-414-228-11
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
< IC >
IC001
IC001
IC301
IC301
IC301
6-714-162-01
6-714-162-11
6-705-359-02
6-705-362-02
6-705-362-11
IC
IC
IC
IC
IC
TEF6617T/V1/S470,518 (E,RU,AR)
TEF6617T/V1/S470/M5,518 (AEP,UK)
TDA8588AJ/N2/R1 (E,AR)
TDA8589AJ/N2/R1 (RU)
TDA8589AJ/N2/R1/M5 (AEP,UK)
IC401
IC402
IC403
6-714-637-01
6-702-302-01
6-712-776-01
IC MB90F882PF-G-103E1
IC TK11133CSCL-G
IC PST8228UL
CDX-GT35U/GT39U/GT39UE
MAIN
Ref. No.
Part No.
Description
IC501
IC503
6-710-965-01
6-709-213-01
IC TPS40200DRG4
IC NJM2387ADL3(TE2)
Remark
IC804
6-714-420-01
IC BD3705FV-E2
< JACK >
J1
J303
J801
1-815-185-13
1-774-698-41
1-566-822-81
JACK (ANTENNA)
JACK, PIN 2P (REAR/SUB AUDIO OUT)
JACK (REMOTE IN) (AEP,UK,RU)
< JUMPER RESISTOR >
JC100
JC101
JC102
JC103
JC104
1-216-296-11
1-216-295-91
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC105
JC106
JC107
JC108
JC109
1-216-295-91
1-216-864-11
1-216-295-91
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC110
JC111
JC112
JC113
JC114
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC115
JC116
JC117
JC118
JC119
1-216-864-11
1-216-296-11
1-216-295-91
1-216-295-91
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC120
JC121
JC122
JC123
JC124
1-216-296-11
1-216-295-91
1-216-295-91
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC125
JC126
JC127
JC128
JC129
1-216-864-11
1-216-295-91
1-216-295-91
1-216-295-91
1-216-295-91
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC130
JC131
JC132
JC133
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
< COIL >
L1
L2
L6
L7
L8
1-414-180-51
1-410-501-61
1-457-817-11
1-481-285-51
1-481-285-51
INDUCTOR
INDUCTOR
COIL (FM MIX)
INDUCTOR
INDUCTOR
3.3uH
2.2uH
L301
L501
L502
L503
L801
1-469-844-11
1-411-595-21
1-406-718-21
1-412-525-31
1-456-617-11
INDUCTOR
COIL, CHOKE
COIL, CHOKE
INDUCTOR
COIL, CHOKE
2.2uH
47uH
68uH
10uH
560uH
560uH
Ref. No.
Part No.
Description
Q104
Q202
Q203
6-551-856-01
6-551-856-01
8-729-027-44
TRANSISTOR LTC614TKFP8T146
TRANSISTOR LTC614TKFP8T146
TRANSISTOR DTC114TKA-T146
Remark
Q204
Q303
Q304
Q305
Q401
6-551-856-01
8-729-027-43
8-729-027-23
8-729-027-23
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q402
Q501
Q502
Q503
Q504
8-729-027-23
8-729-027-43
6-551-923-01
6-550-828-01
8-729-027-43
TRANSISTOR DTA114EKA-T146
TRANSISTOR DTC114EKA-T146
FET TPC6108(T5RSONYF,M
FET RSQ035P03TR
TRANSISTOR DTC114EKA-T146
Q505
Q701
Q802
Q805
Q806
8-729-027-43
8-729-027-43
8-729-027-43
8-729-620-07
8-729-620-07
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q807
Q808
8-729-027-43
8-729-620-07
TRANSISTOR DTC114EKA-T146
TRANSISTOR 2SC3052EF-T1-LEF
LTC614TKFP8T146
DTC114EKA-T146
DTA114EKA-T146
DTA114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
2SC3052EF-T1-LEF
2SC3052EF-T1-LEF (AEP,UK,RU)
< RESISTOR >
R1
R2
R3
R4
R5
1-216-853-11
1-216-853-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
470K
470K
0
0
0
5%
5%
1/10W
1/10W
R6
R10
R11
R12
R13
1-216-843-11
1-216-839-11
1-216-829-11
1-216-009-91
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68K
33K
4.7K
22
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R14
R15
R16
R101
R103
1-216-809-11
1-216-864-11
1-216-864-11
1-216-821-11
1-216-817-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100
0
0
1K
470
5%
1/10W
5%
5%
1/10W
1/10W
R104
R106
R107
R112
R113
1-216-834-11
1-216-813-11
1-216-833-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
220
10K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R117
R201
R203
R204
1-216-813-11
1-216-833-11
1-216-821-11
1-216-817-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
10K
1K
470
12K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R206
R207
R212
R213
R216
1-216-813-11
1-216-833-11
1-216-821-11
1-216-833-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
10K
1K
10K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R217
R222
R302
R303
R304
1-216-833-11
1-216-864-11
1-216-825-11
1-216-823-11
1-216-295-91
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
10K
0
2.2K
1.5K
0
5%
1/10W
5%
5%
1/10W
1/10W
R306
R308
R309
1-216-841-11
1-216-811-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
47K
150
10
5%
5%
5%
1/10W
1/10W
1/10W
< TRANSISTOR >
Q102
Q103
6-551-856-01
8-729-027-44
TRANSISTOR LTC614TKFP8T146
TRANSISTOR DTC114TKA-T146
35
CDX-GT35U/GT39U/GT39UE
Ver. 1.1
MAIN
Ref. No.
Part No.
Description
R311
R313
1-216-841-11
1-216-801-11
METAL CHIP
METAL CHIP
47K
22
5%
5%
1/10W
1/10W
Remark
R401
R402
R404
R405
R406
1-216-845-11
1-216-845-11
1-216-864-11
1-216-849-11
1-216-845-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
100K
0
220K
100K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R407
R408
R409
R410
R411
1-216-825-11
1-216-864-11
1-216-809-11
1-216-817-11
1-216-845-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
0
100
470
100K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
(GT35U/GT39U)
R412
1-216-845-11
METAL CHIP
100K
5%
R413
1-216-845-11
METAL CHIP
100K
5%
R414
1-216-845-11
METAL CHIP
100K
5%
R416
R417
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
100K
100K
5%
5%
1/10W
(GT39UE)
1/10W
(AEP,UK,RU)
1/10W
(E,AR)
1/10W
1/10W
R419
R420
R421
R422
R423
1-216-845-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R424
R426
R427
R428
R429
1-216-833-11
1-216-825-11
1-216-825-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
2.2K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(AEP,UK,RU)
R430
1-216-845-11
METAL CHIP
100K
5%
R431
R432
R433
R434
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
5%
5%
5%
5%
1/10W
(E,AR)
1/10W
1/10W
1/10W
1/10W
R435
R437
R438
R439
R440
1-216-809-11
1-216-809-11
1-216-809-11
1-218-871-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
10K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R441
R442
R443
R444
R445
1-218-871-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
2.2K
2.2K
100K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(E,AR)
R446
R447
R448
R449
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R450
1-216-845-11
METAL CHIP
R451
1-216-845-11
METAL CHIP
100K
R452
1-216-845-11
METAL CHIP
100K
R453
1-216-845-11
METAL CHIP
100K
R454
1-216-845-11
METAL CHIP
100K
36
100K
100K
100K
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
(GT39UE)
100K
5%
1/10W
(GT35U:AEP,UK,RU/GT39U)
1/10W
(GT39UE)
5%
1/10W
(GT35U/GT39U)
5%
1/10W
(AEP,UK,RU)
5%
1/10W
(E,AR)
Ref. No.
Part No.
Description
R455
1-216-809-11
METAL CHIP
100
5%
1/10W
Remark
R456
R459
R460
R461
R462
1-216-833-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R463
R464
R465
R466
R467
1-216-809-11
1-216-809-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
100
100
0
0
0
5%
5%
1/10W
1/10W
R468
R501
R502
R503
R504
1-216-845-11
1-216-842-11
1-216-842-11
1-216-834-11
1-216-843-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
56K
56K
12K
68K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R505
R508
R510
R511
R512
1-216-821-11
1-216-296-11
1-216-845-11
1-216-823-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
1K
0
100K
1.5K
0
5%
1/10W
5%
5%
1/10W
1/10W
R514
R516
R517
R518
R520
1-216-851-11
1-218-895-11
1-218-879-11
1-218-889-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330K
100K
22K
56K
10K
5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R521
R523
R524
R525
R526
1-218-859-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
1K
1K
1K
10
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R527
R528
R600
R701
R703
1-216-797-11
1-216-864-11
1-216-845-11
1-216-864-11
1-216-845-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10
0
100K
0
100K
5%
1/10W
5%
1/10W
5%
1/10W
R704
R706
R707
R709
R710
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-845-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
100
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R712
R713
R714
R717
R801
1-216-864-11
1-216-845-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
100K
5%
0
0
0 (AEP,UK,RU)
R802
R815
R816
R817
R818
1-216-864-11
1-216-821-11
1-216-821-11
1-216-841-11
1-216-829-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0 (AEP,UK,RU)
1K
5%
1K
5%
47K
5%
4.7K
5%
R819
R820
1-216-841-11
1-216-833-11
METAL CHIP
METAL CHIP
47K
10K
5%
5%
R821
1-216-833-11
METAL CHIP
10K
5%
R822
1-216-841-11
METAL CHIP
47K
5%
R823
1-249-425-11
CARBON
4.7K
5%
R824
1-216-049-11
METAL CHIP
1K
5%
R825
1-216-864-11
SHORT CHIP
0
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
(AEP,UK,RU)
1/10W
(AEP,UK,RU)
1/10W
(AEP,UK,RU)
1/4W
1/10W
(AEP,UK,RU)
CDX-GT35U/GT39U/GT39UE
MAIN
Ref. No.
Part No.
Description
R826
R827
R829
1-216-864-11
1-216-849-11
1-216-864-11
SHORT CHIP
METAL CHIP
SHORT CHIP
0 (AEP,UK,RU)
220K
5%
0
Remark
R830
R831
R832
R833
1-216-864-11
1-216-833-11
1-216-833-11
1-216-864-11
SHORT CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
10K
10K
0
5%
5%
Ref. No.
1-786-826-11
1-571-478-11
SWITCH, TACTILE (RESET)
SWITCH, SLIDE (FREQUENCY SELECT) (E,AR)
< SURGE ABSORBER >
VR1
1-805-043-11
Remark
151
152
153
153
X-2179-431-2
1-465-459-41
1-776-527-11
1-831-838-11
154
1-833-974-11
155
156
157
158
159
3-876-675-01
3-873-543-02
X-3381-154-1
X-3382-926-1
3-349-410-11
KEY (FRAME)
COLLAR
SCREW ASSY (BS4) (E,AR)
SCREW ASSY (BS) (AEP,UK,RU)
BUSHING
160
3-934-325-01
SCREW, +K (5X8) TAPPING (E,AR)
< SWITCH >
S401
S402
Description
PARTS FOR INSTALLATION AND CONNECTIONS
*************************************
1/10W
1/10W
1/10W
Part No.
Ver. 1.1
SERVO
FRAME ASSY, FITTING
ADAPTOR, ANTENNA (AEP,UK,RU,AR)
CORD (WITH CONNECTOR) (ISO) (POWER) (AR)
CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK,RU)
CONNECTION CORD FOR AUTOMOBILE
(POWER) (E)
ABSORBER, CHIP SURGE
< VIBRATOR >
X1
1-814-302-11 QUARTZ CRYSTAL UNIT (4MHz)
X401
1-814-207-21 VIBRATOR, CERAMIC (7.92MHz)
X402
1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
SERVO BOARD, COMPLETE
**********************
*************************************************************
151
152
153
154
155
156
A-1555-002-A
MISCELLANEOUS
**************
6
6
1-776-527-11
1-831-838-11
CORD (WITH CONNECTOR) (ISO) (POWER) (AR)
CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK,RU)
6
1-833-974-11 CONNECTION CORD FOR AUTOMOBILE
(POWER) (E,AR)
0 103
X-2149-672-1 SERVICE ASSY, OP (DAX-25A)
FU601
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
*************************************************************
ACCESSORIES
************
1-479-077-14
2-548-729-01
4-156-428-11
4-156-428-21
4-156-428-31
REMOTE COMMANDER (RM-X151) (E,AR)
LID, BATTERY CASE (for RM-X151) (E,AR)
MANUAL, INSTRUCTION (ENGLISH,GERMAN,
FRENCH,ITALIAN,DUTCH) (AEP,UK)
MANUAL, INSTRUCTION (RUSSIAN,UKRAINIAN)
(RU)
MANUAL, INSTRUCTION (ENGLISH,SPANISH)
(E,AR)
u2
157
159
160
u4
158
159
4-156-429-11
MANUAL, INSTRUCTION, INSTALL (ENGLISH,
GERMAN,FRENCH,ITALIAN,DUTCH) (AEP,UK)
4-156-429-21 MANUAL, INSTRUCTION, INSTALL (RUSSIAN,
UKRAINIAN) (RU)
4-156-429-31 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH) (E)
4-156-429-41 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH) (AR)
*************************************************************
37
CDX-GT35U/GT39U/GT39UE
REVISION HISTORY
Checking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
Ver.
Date
Description of Revision
1.0
2009.11
New
1.1
2010.02
Addition of Argentina model of CDX-GT35U.