Download Aiwa JAX-S5 Service manual

CX-JN10
SERVICE MANUAL
AEP Model
UK Model
E Model
Australian Model
Ver 1.0 2004.03
CX-JN10 is the tuner, amplifier, cassette deck
and CD player section in JAX-N10/PK10.
CD
Section
Tape deck
Section
Model Name Using Similar Mechanism
CX-JN1
CD Mechanism Type
CDM74S-K6BD72
Base Unit Name
BU-K6BD72
Optical Pick-up Block Name
KSM-213DCP
Optical Pick-up Name
KSS-213D
Model Name Using Similar Mechanism
CX-JN1
Tape Transport Mechanism type
CWM43FF13
SPECIFICATIONS
TUNER
FM tuning range
FM usable sensitivity (IHF)
AEP, UK models:
Except AEP, UK models:
FM antenna terminal
AM tuning range
AEP, UK, E, EA, TW models:
E51 model:
SP, AUS models:
AM usable sensitivity
AM antenna
CASSETTE DECK
87.5 MHz to 108 MHz
16.8 dBf
13.2 dBf
75 ohms (unbalanced)
531 kHz to 1602 kHz
530 kHz to 1710 kHz (10 kHz step)
531 kHz to 1710 kHz (9 kHz step)
531 kHz to 1602 kHz (9 kHz step)
530 kHz to 1710 kHz (10 kHz step)
350 µV/m
Loop antenna
AMPLIFIER
Power output
AEP, UK models:
Except AEP, UK models:
Total harmonic distortion
Input
Outputs
Rated: 12 W + 12 W (6 ohms, T.H.D.
1 %, 1 kHz/DIN 45500)
Reference: 15 W + 15 W (6 ohms,
T.H.D. 10 %, 1 kHz/DIN 45324)
MUSIC POWER: 27 W +27 W
Rated: 36 W + 36 W (1 kHz, T.H.D. 1
%, 6 ohms)
Reference: 45 W + 45 W (1 kHz,
T.H.D. 10 %, 6 ohms)
0.08 % (6 W, 1 kHz, 6 ohms, DIN
AUDIO)
VIDEO/AUX: 400 mV
MIC: 1.7 mV (10k ohms)
(Except AEP, UK models)
SPEAKER: 6 ohms or more
PHONES: 32 ohms or more
Track format
Frequency response
Recording system
Heads
4 tracks, 2 channels stereo
50 Hz – 8 kHz
AC bias
Deck A: playback x 1
Deck B: recording/playback x 1,
erase x 1
CD PLAYER
Laser
D/A converter
Signal-to-noise ratio
Harmonic distortion
Semiconductor laser
(λ = 780 nm)
Emission duration:
continuous
1 bit dual
85 dB (1 kHz, 0 dB)
0.05 % (1 kHz, 0 dB)
GENERAL
Power requirements
AEP, UK models:
E, E51, SP models:
EA model:
TW model:
AUS model:
9-877-593-01
Sony Corporation
2004C05-1
© 2004.03
Home Audio Company
Published by Sony Engineering Corporation
230 V AC, 50/60 Hz
110 - 120V / 220 - 240V AC
(Switchable), 50 Hz/60 Hz
120 - 127V / 220 V AC
(Switchable), 50 Hz/60 Hz
120 V AC, 50 Hz/60 Hz
240 V AC, 50 Hz/60 Hz
Power consumption
AEP, UK models:
Except AEP, UK models:
Power consumption
in standby mode
Dimensions (W x H x D)
Weight
AEP, UK models:
E51 model:
E, EA, SP, TW, AUS models:
40 W
74 W
With ECO mode on: 0.25 W
With ECO mode off: 15 W
280 x 330 x 392.5 mm
6.1 kg
6.7 kg
6.8 kg
Specifications and external appearance are subject to change
without notice.
COPYRIGHT
Check copyright laws relevant to recordings from discs, tuner
or tape for the country where the unit is to be used.
• Abbreviation
AUS : Australian model
E51 : Chilean and Peruvian models
EA : Saudi Arabia model
SP : Singapore model
TW : Taiwan model
COMPACT DISC DECK RECEIVER
CX-JN10
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 °C during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
This appliance is classified as
a CLASS 1 LASER product.
The CLASS 1 LASER
PRODUCT MARKING is
located on the rear exterior.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
CX-JN10
TABLE OF CONTENTS
1.
2.
SERVICING NOTES ................................................ 4
GENERAL
Location of Controls ....................................................... 7
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
Disassembly Flow ...........................................................
Case (SIDE-L/R) .............................................................
Case (Top) .......................................................................
Tray Panel ........................................................................
CD Mechanism Deck (CDM74S-K6BD72) ...................
Front Panel Section .........................................................
Mechanical Deck (CWM43FF13) ..................................
Rear Cabinet Section ......................................................
PT Board, MAIN Board ..................................................
Table Assy .......................................................................
Motor (TB) Board ...........................................................
Motor (LD) Board ...........................................................
Base Unit (BU-K6BD72) ................................................
Motor Gear Assy (Sled) (M701), BD Board ..................
4.
TEST MODE .............................................................. 17
5.
ELECTRICAL ADJUSTMENTS
9
10
10
11
11
12
12
13
13
14
14
15
15
16
CD Section ...................................................................... 19
6.
DIAGRAMS
6-1.
6-2.
6-3.
6-4.
Block Diagram – CD Section – .....................................
Block Diagram – TUNER/TAPE/PANEL Section – .....
Block Diagram – AMP/POWER SUPPLY Section – ...
Note for Printed Wiring Boards and
Schematic Diagrams .......................................................
Printed Wiring Board – BD Section – ...........................
Schematic Diagram – BD Section – ..............................
Printed Wiring Boards – CHANGER Section – ............
Schematic Diagram – CHANGER Section – ................
Schematic Diagram – MAIN Section (1/4) – ................
Schematic Diagram – MAIN Section (2/4) – ................
Schematic Diagram – MAIN Section (3/4) – ................
Schematic Diagram – MAIN Section (4/4) – ................
Printed Wiring Board – MAIN Section – ......................
Printed Wiring Board – HP Section – ...........................
Schematic Diagram – HP Section – ..............................
Printed Wiring Board – PANEL Section – ....................
Schematic Diagram – PANEL Section – .......................
Printed Wiring Boards – KEY Section – .......................
Schematic Diagram – KEY Section – ...........................
Printed Wiring Board – PT Section –
(AEP, UK, AUS) ..............................................................
Schematic Diagram – PT Section –
(AEP, UK, AUS) ..............................................................
Printed Wiring Board – PT Section –
(E, EA, E51, SP, TW) .....................................................
Schematic Diagram – PT Section –
(E, EA, E51, SP, TW) .....................................................
6-5.
6-6.
6-7.
6-8.
6-9.
6-10.
6-11.
6-12.
6-13.
6-14.
6-15.
6-16.
6-17.
6-18.
6-19.
6-20.
6-21.
6-22.
6-23.
7.
EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
Case Section ....................................................................
Tape Deck Section ..........................................................
Panel Board Section ........................................................
Key Section .....................................................................
Front Cabinet Section .....................................................
Chassis Section ...............................................................
CD Mechanism Deck Section-1
(CDM74S-K6BD72) .......................................................
7-8. CD Mechanism Deck Section-2
(CDM74S-K6BD72) .......................................................
7-9. CD Mechanism Deck Section-3
(CDM74S-K6BD72) .......................................................
7-10. Base Unit Section (BU-K6BD72) ..................................
8.
47
48
49
50
51
52
53
54
55
56
ELECTRICAL PARTS LIST ............................... 57
• Abbreviation
AUS : Australian model
E51 : Chilean and Peruvian models
EA : Saudi Arabia model
SP : Singapore model
TW : Taiwan model
•
20
21
22
23
24
25
26
27
28
29
30
31
32
33
33
34
35
36
37
38
39
40
41
3
CX-JN10
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
• MODEL IDENTIFICATION
– Back Panel –
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
PART No.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the “S curve check” in “CD section adjustment” and
check that the S curve waveforms is output three times.
MODEL
AEP and UK models
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
RELEASING THE DISC TRAY LOCK
The disc tray lock function for the antitheft of an demonstration
disc in the store is equipped.
Releasing Procedure :
While pressing the x key, press the OPEN/CLOSE Z key for 5
seconds. The message “UNLOCKED” is displayed and the tray is
unlocked.
Note: When “LOCKED” is displayed, the tray lock is not released by
turning power on/off with the [POWER] key.
4
Taiwan model
PART No.
No model number label
4-248-949-2[]
Singapore model
4-249-031-6[]
Australian model
4-249-128-2[]
Saudi Arabia model
4-249-129-6[]
E model
4-249-130-8[]
Chilean and Peruvian models
4-249-802-3[]
CX-JN10
HOW TO OPEN THE DISC TRAY WHEN POWER SWITCH TURNS OFF.
1 Remove the case (side-L).
2 Turn the loading gear in the direction of arrow A.
A
3 Pull-out the disc tray.
5
CX-JN10
SERVICE POSITION
– CD mechanism deck –
main board (CN691)
Connect wire (flat type) (19 core) to
main board (CN691) and BD board (CN710).
BD board (CN710)
– Tape mechanism deck –
panel board (CN601)
main board (CN302)
Connect wire (flat type) (13 core) to
panel board (CN601) and mechanical deck.
6
main board (CN301)
CX-JN10
SECTION 2
GENERAL
This section is extracted from
instruction manual.
• LOCATION OF CONTROLS
Main unit: front
Refer to the pages indicated in parentheses for details.
5 MULTI JOG
When used in combination with ENTER and MULTI
JOG,
CD: selects a track and Repeat/Shuffle/Programmed
playback.
Tuner: selects a preset station.
Tape: specifies tape length.
Clock and Timer: sets the time.
ECO and Dimmer: selects the mode.
6 PHONES jack
Plug in here an optional headphones set with a mini
stereo plug (ø3.5 mm). Speaker output is canceled.
1 DISC CHANGE
Rotates the CD trays.
2 POWER 6STANDBY/ON
Switches the unit on and off (standby).
The red indicator flashes when receiving a signal from
the remote.
3 MODE
Selects various modes (ECO and Repeat/Shuffle/
Programmed playback, etc.) when used in combination
with ENTER and MULTI JOG.
4 ENTER
Fixes the modes and the time (ECO, Repeat/Shuffle/
Programmed playback, clock, and timer, etc.) when
used in combination with ENTER and MULTI JOG.
! Remote sensor
Receives a signal from the remote.
@ VOLUME
Adjusts the volume.
# TREBLE
Enhances high frequency sound.
$ BASS
Emphasizes low frequency sound.
% i-Bass
Produces rich and clear low frequency sound.
7 SYNC DUB
Starts dubbing a whole tape.
^ PTY (AEP, UK models)
Displays a program type for RDS (Radio Data System)
wREC/REC MUTING
Starts recording.
RT (AEP, UK models)
Displays text information for RDS (Radio Data System)
8 DISC DIRECT PLAY 1-3
Selects a disc.
9 zOPEN/CLOSE
Opens or closes the disc compartment.
0 TAPE A/B
Selects Tape function, and deck A or B.
TUNER/BAND
Selects Tuner function and the radio band.
VIDEO/AUX
Selects the function of external equipment connected
to VIDEO/AUX jacks.
CD
Selects CD function.
& cPLAY/PRESET
When the unit is turned off: activates or deactivates
DEMO.
CD and Tape: starts playback.
Tuner: tunes into a preset station.
sSTOP/CLEAR
CD and Tape: stops playback.
Tuner: clears a station preset.
fTUNING DOWN, gTUNING UP
CD: searches a track in fast forward or fast reverse
playback when held down.
Tape: fast forwards or rewinds the tape.
Tuner: manually tunes down or up within the band.
aPAUSE/SET
CD and Tape: pauses playback.
Tuner: stores the received station in to preset.
* MIC MIXING (Except AEP, UK models)
Adjusts the microphone volume.
MIC jack (Except AEP, UK models)
Connects the microphone here.
Main unit: rear
Refer to the pages indicated in parentheses for details.
1 AM LOOP, FM 75 Ω terminals
Plug in the supplied AM and FM antennas here.
2 VIDEO/AUX jacks
Accepts analog sound signals from external equipment.
Connect using an optional connecting cable with RCA
phono plugs (red plug to R jack, white plug to L jack).
Refer also to the operating instructions of your equipment.
To switch function to external input, press VIDEO/AUX.
Tip:
To change the displayed name for this function, turn the
unit on, then hold down VIDEO/AUX and press POWER
on the unit. Repeat the procedure to select "VIDEO",
"AUX" or "TV".
3 # SPEAKER terminals
Connect the speaker cord of the supplied front speakers
here.
4 AC voltage selector (E, Saudi Arabia,
Chilean, Peruvian, Singapore models)
Switches AC voltage between 110 - 120V and 220 - 240V.
(E, Chilean, Peruvian, Singapore models)
Switches AC voltage between 110 - 127V and 220 - 240V.
(Saudi Arabia model)
Make sure it matches your local voltage.
5 AC power cord
7
CX-JN10
Remote control
TAPE A/B
Refer to the pages indicated in parentheses for details.
TUNER MODE
Switches between stereo or monaural FM reception.
3 r, t
CD: selects a track.
Tuner: selects a preset station.
Tape: specifies tape length.
BASS and TREBLE: adjusts the level.
Clock and Timer: sets the time.
4 PLAY MODE
Selects Shuffle or Programmed playback in CD
function.
REPEAT
Enters CD repeat playback mode.
ENTER
Buttons with the same or similar names with the main
unit basically have the same function.
1 POWER
2 1-0/10, +10
CD: selects a CD track of the specified number.
Tuner: tunes in to the station with the specified preset
number.
The numbered buttons take on these functions below when
pressed with SHIFT held down:
EDIT
Enters AI Edit Recording or Programmed Edit Recording
mode when pressed in stop mode.
BAND
Selects Tuner function and the radio band.
Setting the clock
Use the remote.
1 Press CLOCK/TIMER/SET.
Go to step 3 when the time appears and the 'hour' flashes.
2 Press r or t repeatedly until "CLOCK
SET" appears in the display and then press
ENTER.
3 Press r or t repeatedly to set the hour
and then press ENTER.
4 Press r or t repeatedly to set the minute
and then press ENTER.
The time display stops flashing and the clock starts from
00 seconds.
•MULTI JOG is also available in place of r or t.
8
5 CLOCK/TIMER/SET
Enters timer setting mode.
CLOCK/TIMER/SELECT
Selects timer playback, timer recording or timer off.
6 DISPLAY
Displays the time and the remaining time for CD.
7 SHIFT
Hold down when pressing a numbered button to change
its function to that printed above the number.
e.g.)
"Press SHIFT+BAND on the remote" indicates "Hold
down SHIFT and press '2' (BAND)". Doing so makes
you be able to select Tuner function and the radio band.
You can first press SHIFT, then a numbered button.
8 FUNCTION
Switches the active function among CD, TAPE, TUNER
and VIDEO (AUX or TV).
To display the time
Press DISPLAY on the remote. The time will be displayed for
6 seconds.
Tip: (Except AEP, UK models)
"AM 12:00" indicates midnight and "PM 12:00" noon.
If "- -:- -" appears when the unit is turned off
There has been a power interruption. Re-set the clock.
9 DISC SKIP
Select a disc.
0 c/d
When the unit is turned off: activates or deactivates
DEMO.
CD and Tape: starts playback.
s
CD and Tape: stops playback.
f,g
CD: searches a track in fast forward or fast reverse
playback when held down.
Tape: fast forwards or rewinds the tape.
Tuner: manually tunes down or up within the band.
a
CD and Tape: pauses playback.
! SLEEP
Switches the sleep-timer on/off and selects the
duration.
@ VOLUME (+, -)
Adjusts the volume.
# SOUND
Selects BASS or TREBLE setting mode
CLEAR
Clears a track of the CD programmed playback and a
Radio preset station.
Note
The buttons not explained above (ALBUM N, M,
SPECTRUM and KARAOKE) do not operate for this
unit.
CX-JN10
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1.
DISASSEMBLY FLOW
Note 1:
The process described in
can be performed in any order.
Note 2:
Without completing the process described in
, the next process can not be performed.
SET
3-2. CASE
(SIDE-L/R)
(Page 10)
3-3. CASE (TOP)
(Page 10)
3-4. TRAY PANEL
(Page 11)
3-5. CD MECHANISM DECK
(CDM74S-K6BD72)
(Page 11)
3-6. FRONT PANEL
SECTION
(Page 12)
3-8. REAR CABINET
SECTION
(Page 13)
3-10. TABLE ASSY
(Page 14)
3-13. BASE UNIT
(BU-K6BD72)
(Page 15)
3-7. MECHANICAL
DECK
(CWM43FF13)
(Page 12)
3-9. PT BOARD,
MAIN BOARD
(Page 13)
3-11. MOTOR (TB)
BOARD
(Page 14)
3-14. MOTOR GEAR ASSY (SLED) (M701),
BD BOARD
(Page 16)
3-12. MOTOR (LD)
BOARD
(Page 15)
9
CX-JN10
Note: Follow the disassembly procedure in the numerical order given.
3-2.
CASE (SIDE-L/R)
2 two screws
(BVTP3 × 10)
5 case (side-L)
1 two case screws
2 two screws
(BVTP3 × 10)
3
4
1 case screw
1 two case screws
3
4
5 case (side-R)
1 case screw
3-3.
CASE (TOP)
1 two screws
(BVTP3 × 10)
2 claw
4 case (top)
3
2 claw
2 claw
2 claw
10
CX-JN10
3-4.
TRAY PANEL
1 Turn the loading gear
in the direction of arrow A.
A
2 Pull-out the disc table.
3 four claws
4 tray panel
3-5.
CD MECHANISM DECK (CDM74S-K6BD72)
5 CD mechanism deck
(CDM74S-K6BD72)
1 wire (flat type) (19 core)
(CN691)
2 connector
(CN701)
3 screw
(BVTP3 × 10)
4 two screws
(BVTP3 × 10)
3 screw
(BVTP3 × 10)
11
CX-JN10
3-6.
FRONT PANEL SECTION
1 screw
(BVTP3 × 10)
3 screw
(BVWHTP)
2 terminal
4 HP board
8 connector
(CN101)
5 wire (flat type) (11 core)
(CN694)
6 connector
(CN302)
6 connector
(CN301)
9 front panel section
7 three screws
(BVTP3 × 10)
3-7.
MECHANICAL DECK (CWM43FF13)
4 mechanical deck
(CWM43FF13)
3 clamp
2 six screws
(BVTP3 × 10)
5 ground mechanical plate
1 wire (flat type) (13 core)
12
CX-JN10
3-8.
REAR CABINET SECTION
3 rear cabinet section
1 wire (flat type)
(11 core: EXCEPT AEP, UK) (CN801)
(15 core: AEP, UK) (CN802)
2 three screws
(BVTP3 × 10)
2 screw
(BVTP3 × 10)
3-9.
PT BOARD, MAIN BOARD
• Abbreviation
E51 : Chilean and peruvian models
EA
: Saudi Arabia model
: Singapore model
: Taiwan model
(E, EA, E51, SP, TW)
(EXCEPT E, EA, E51, SP, TW)
6 screw
(BVTP3 × 10)
SP
TW
5 screw
(BV B3)
8 two screws
7 two screws
7 two screws
8 two screws
4 screw
(BVTT3 × 8)
A
A
4 screw
(BVTT3 × 8)
5 clamp
8 PT board
9 PT board
7 Remove the PWB PT HLDR
in the direction of the arrow.
6 Remove the PWB PT HLDR
in the direction of the arrow.
A
3 connector
(CN090) (E, EA, E51, SP, TW)
(CN091) (EXCEPT E, EA, E51, SP, TW)
1 screw (BV B3)
1 two screws
(BV B3)
2 MAIN board
13
CX-JN10
3-10. TABLE ASSY
5 two claws
A
4 hook
3 wire (flat type) (5 core)
(CN702)
1 Turn the loading gear
in the direction of arrow A.
2 Pull-out the table assy.
6 table assy
3-11. MOTOR (TB) BOARD
1 screw
(PTPWH M2.6)
2 table (loading)
3 belt (table)
6 MOTOR (TB) board
4 connector
(CN731)
5 two screws
(BTTP M2.6)
14
CX-JN10
3-12. MOTOR (LD) BOARD
3 two screws
(BTTP M2.6)
4 MOTOR (LD) board
2 connector
(CN704)
1 belt (loading)
3-13. BASE UNIT (BU-K6BD72)
6
9 base unit
(BU-K6BD72)
7 three insulators
3 three coil springs
(insulator)
2 three stoppers (BU)
1 three screws
(BTTP M2.6)
8 insulator
5 coil spring
(insulator)
4 screw
(PTPWH M2.6)
15
CX-JN10
3-14. MOTOR GEAR ASSY (SLED) (M701), BD BOARD
7 gear (A)
6 claw
8 gear (B)
2 two screws
(P2 × 3)
5 wire (flat type) (16 core)
(CN708)
qa BD board
0 motor gear assy (SLED)
(M701)
1 Remove two
solders.
4
3 screw (BTP2.6 × 8)
9 Remove two solders.
16
CX-JN10
SECTION 4
TEST MODE
MC COLD RESET
• The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. In the standby status, while pressing the x button, press the
[POWER] button.
2. The set is reset, then becomes standby status.
GC TEST MODE
Procedure:
1. Press the [POWER] button to turn the power on.
2. While pressing the x button, press the [POWER] button for
5 seconds.
3. It change displays in order of model type, version and suffix at
2 seconds interval, then the display is back to normal status.
AMP TEST MODE
Procedure:
1. In the status where AC plug is disconnected, while pressing
the [VIDEO/AUX] button, connect the AC plug to turn the
power on. Then enter the AMP test mode and display “AMP
TEST”.
2. If turn the [VOLUME] knob clockwise, it displays “VOLUME
MAX”, and if turn the knob counterclockwise, it displays
“VOLUME 0”.
3. If the [TREBLE] and [BASS] knobs are turned clockwise or
counterclockwise, it change displays in order of “EQ MAX”,
“EQ MIN” and “EQ FLAT”.
4. To release from this mode, disconnect the AC plug and turn
the power off.
CHANGE-OVER OF AM TUNER STEP BETWEEN
9 kHz AND 10 kHz (Except AEP and UK models)
• A step of AM channels can be changed over between 9 kHz and
10 kHz.
Procedure:
1. Press the [POWER] button to turn the power on.
2. While pressing the [TUNER] button, press the [POWER] button to the display on fluorescent indicator tube changes to “AM
530 kHz” (10 kHz step) or “AM 531 kHz” (9 kHz step), and
thus the channel step is changed over.
FUNCTION CHANGE MODE
• Select either TV, VIDEO or AUX (MD) of the external function
input.
Procedure:
1. Press the [POWER] button to turn the power on.
2. While pressing the [VIDEO/AUX] button, press the [POWER]
button.
3. Each time this operation is operated, it change displays in order of “TV”, “VIDEO” and “AUX”.
DISC TRAY LOCK
Procedure:
1. Press the [POWER] button to turn the power on.
2. While pressing the x button, press the OPEN/CLOSE Z
button for 5 seconds.
3. The message “LOCKED” is displayed and the tray is locked.
(Even if exiting from this mode, the tray is still locked)
4. To release this lock, while pressing the x button, press
the OPEN/CLOSE Z button for 5 again.
5. The message “UNLOCKED” is displayed and the tray is unlocked.
CD REPEAT 5 LIMIT CANCEL MODE
• Number of repeat for CD playback is 5 times when the repeat
mode is “REPEAT”. This mode enables CD to repeat playback
for limitless times.
Procedure:
1. Press the [POWER] button to turn the power on.
2. In the repeat on status, while pressing the x button, press the
[CD] button to enter the CD repeat 5 limit cancel mode and
repeat mark blinks on the fluorescent indicator tube.
3. To release this mode, press the [POWER] button to turn the
power off.
17
CX-JN10
CD TEST MODE
• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pickup.
Procedure:
1. In the status where AC plug is disconnected, while pressing
the [CD] button, connect the AC plug to turn the power on.
2. When enter this mode, it displays “CD TEST” and few seconds later, all segments turn on of the fluorescent indicator
tube.
3. To release from this mode, disconnect the AC plug and turn
the power off.
In this mode, it operates as following table.
Button
Operation
Purpose of use
M
Move the pick-up to outside track
Sled circuit check
m
Move the pick-up to inside track
Tracking circuit check
Mechanism operation check
Optical pick-up check
N
Playback a CD
Servo block check
If it cannot focus on, it continuous focus search
x
When playback a CD: stop playback
When stop a CD:
Laser current measure
display “READING” (blink)
Focus search waveform check
continuous laser diode on
Tracking balance check
continuous focus search (not made focus on)
X
Pause, Tracking servo off
(ignore CLV error)
18
APC circuit check
CX-JN10
SECTION 5
ELECTRICAL ADJUSTMENTS
Note: Clear RF signal waveform means that the shape “ ◊ ” can be clearly
distinguished at the center of the waveform.
CD SECTION
Note:
1. CD Block is basically designed to operate without adjustment. Therefore,
check each item in order given.
2. Use YEDS-18 (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10MΩ impedance.
4. Clean the object lens by an applicator with neutral detergent when the
signal level is low than specified value with the following checks.
RF signal waveform
VOLT/DIV : 200mV
TIME/DIV : 500ns
level : 1.3 ±0.3Vp-p
S-CURVE CHECK
Oscilloscope
BD board
Connecting Location: BD board
TP(FE)
TP(VC)
– BD Board (Conductor side) –
Procedure :
1. Connect an oscilloscope to TP (FE) and TP (VC).
2. Turn the power on.
3. Load a disc (YEDS-18) and actuate the focus search. (In
consequence of open and close the disc tray, actuate the focus
search)
4. Confirm that the oscilloscope waveform (S-curve) is
symmetrical between A and B. And confirm peak to peak level
within 3 ± 0.5 Vp-p.
S-curve waveform
symmetry
A
TP (VC)
within 3 ±0.5Vp-p
B
Note: • Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.
• Take sweep time as long as possible and light up the
brightness to obtain best waveform.
TP (RF)
TP (FE)
IC721
RF LEVEL CHECK
oscilloscope
BD board
TP(RF)
TP(VC)
Procedure :
1. Connect an oscilloscope to TP (RF) and TP (VC).
2. Turn the power on.
3. Load a disc (YEDS-18) and playback.
4. Confirm that oscilloscope waveform is clear and check if RF
signal level is correct or not.
19
19
CX-JN10
SECTION 6
DIAGRAMS
6-1.
BLOCK DIAGRAM – CD Section –
OPTICAL PICK-UP
BLOCK
(KSM-213DCP)
CD DSP
IC721
A
8
FIN2
LCHO
DETECTOR
A
D
I-V AMP
D
C
B
7
RF
EQ,
AGC
RF AMP
4
3
EFMIN
ERROR
CORRECT
D/A
CONVERTER
B
9
EXTERNAL
AUDIO IN
ASDFIN
57
ASDACK
56
ASLRCK
55
SERIAL OUT
DATA
60
DATACK
59
LRSY
58
TIN1
10
TIN2
LASER DIODE
SERVO
PROCESSOR
AUTOMATIC
POWER CONTROL
Q701
LD
80
16MOUT
XIN
APC
D/A
CONVERTER
PD
79
S701
(LIMIT IN)
CLOCK
GENERATOR
XOUT
X701
16.9344MHz
COMMAND
INTERFACE
70 LIMIT SW
DO
DI
CL
CE
WRQ
64
63
62
61
65
99
98
100
5
97
CD DO
CD DI
CD CLK
CD CE
CD WRQ
CONT4
TDO
FDO
SLDO
SPDO
(TRACKING)
(FOCUS)
P-DOWN
+
M
DISC TRAY
ADDRESS DETECT
S751
OPEN/CLOSE
DETECT
OPEN
TIN 20
CLOSE
FOIN 10
M751
(LOADING)
M
4 OUT1
FIN 7
2 OUT2
RIN 9
LM-F
LM-R
TABLE MOTOR DRIVE
IC712
26 VO4 (+)
SLIN 25
2 VO1 (+)
1 VO1 (–)
ROTARY
ENCODER
S711
SYSTEM CONTROLLER
IC901 (1/2)
M741
(TABLE)
M702
(SPINDLE)
TABLE ADDRESS
SENSOR
IC731
LEVEL SHIFT
Q731
CD NUMBER SENS 74
25
LOADING MOTOR DRIVE
IC701
27 VO4 (–)
RESET,
P-DOWN
RESET
95 CD DRF
4 CD RESET
SLED/SPINDLE MOTOR DRIVE,
FOCUS/TRACKING COIL DRIVE
IC722
M
MUTE,
POWER,
HOLD
MUTE
POWER
HOLD
SYS-MUTE 1
POWER 94
HOLD 27
CD BUSY 20
M701
(SLED)
(Page 22)
48
LDS
20 21 23 22
11 VO2 (+)
12 VO2 (–)
C
49
DRF 67
RES 66
18 VO3 (+)
17 VO3 (–)
(Page 22)
54
RESET 11
POWER DOWN 18
2-AXIS
DEVICE
B
: CD PLAY
LDD
LD
PD
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
EFLG
53
C2F
52
FSX/16MIN
50
A/D
CONVERTER
TBAL
F
(Page 22)
R-CH
C
E
F
45
A
FIN1
PH, BH
E
RCHO
CD
42
SPIN 3
MUTE 7
20
20
M
4 OUT1
2 OUT2
FIN 7
RIN 9
TM-F
TM-R
LM-L, LM-R,
TM-L, TM-R
D
(Page 22)
CX-JN10
6-2.
BLOCK DIAGRAM – TUNER/TAPE/PANEL Section –
PB,
REC
PB
PB SWITCH
Q301
L-CH
F
(Page 22)
G
(Page 22)
REC
HP1
(PB)
(DECK-A)
R-CH
R-CH
TUNER PACK
FM 75Ω
(COAXIAL)
FM ANT
R-CH
AM LOOP
TU
L-CH
E
(Page 22)
R-CH
PB SWITCH
Q303
L-CH
AM ANT
MUTING
Q305
R-CH
HRPE1
(REC/PB/ERASE)
(DECK-B)
BIAS OSC
L311
REC BIAS
SWITCH
Q311, 312
B+
(CD-VM)
ERASE
MUTING
Q307, 309
BIAS OSC
Q310
RDS-DATA
RDS-CLK
RDS-SIG
Q601
DATA, CLK,
S-OUT, LCK
DATA
CLK
(AEP, UK)
LCK
S-OUT
RDS DATA
RDS INT
FM-SOUT
DATA
IFC
CLK
PLL-CE
TUNED
STEREO
TU-MUTE
CLK
DATA
DO
DI
CL
CE
TUNED
STEREO
MUTE
R-CH
R-CH
DATA
IFC
CLK
PLL-CE
TUNED
STEREO
TU-MUTE
RDS-DATA
RDS-CLK
RDS-SIG
3
96
88
9
75
76
85
TU/EVOL DO
TU DI
CLK
TU CE
TUNED
STEREO
TUNER MUTE
2 RDS DO
28 RDS CLK
19 TU-SIG/MIC
6
PB2
SYSTEM CONTROLLER
IC901 (2/2)
LCK
O-BIAS 7
TAPE MECHANISM
DECK BLOCK
18 SO
5 LCK
8
O-MOTOR 8
3 DATA
4 CLK
XT1 12
X901
32.768kHz
CAPM+
PLUNGER DRIVE
(DECK-A)
Q602, 605
A-SOL
SOL B 10
PLUNGER DRIVE
(DECK-B)
Q603, 606
B-SOL
X902
8.64MHz
M
(CAPSTAN/REEL)
SOL A 9
XT2 13
CF1 15
CAPSTAN/REEL
MOTOR DRIVE
Q601, 604
(DECK-A)
(DECK-B)
CF2 16
(AEP, UK)
(Page 22)
H
MIC
LED201
11 V-BASS
i-BASS
(EXCEPT AEP, UK)
S6
LED901
POWER LED 93
ROTARY
ENCODER
S801
77 VOL A
78 VOL B
TREBLE
ROTARY
ENCODER
S803
81 TRE A
82 TRE B
BASS
ROTARY
ENCODER
S802
83 BASS A
84 BASS B
MULTI JOG
ROTARY
ENCODER
S804
79 JOG A
80 JOG B
KEYSCAN 92
KEY1 –
KEY3
47
48
54
52
55
50
53
49
S14 – S25
S1 – S5,
S26 – S30
: REC
REMOTE CONTROL
RECEIVER
IC801
S6
S7
S12
S10
S13
S9
S11
S8
D620 – 627
S6 – S13
A PHOTO/S6
B PHOTO/S7
A HALF/S12
B HALF/S10
A MODE/S13
B MODE/S9
REC FWD/S11
REC REV/S8
56-67
S301 – 315,
S317 – 323
(FRONT PANEL KEY)
B+
FL902
FLUORESCENT
INDICATOR TUBE
41-45,
68-71, 73
: TAPE PLAY (DECK-B)
26 – 24
: TUNER (FM/AM)
: TAPE PLAY (DECK-A)
B+ SWITCH
Q607
29 RMC
G1 – G11
21
30-40
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
VOLUME
MOTOR/PLUNGER DRIVE,
LED DRIVE
IC201
1 STANDBY/ON
21
+3.3V
S7
S12
S10
S13
S9
S11
S8
A-PHOTO
B-PHOTO
A-HALF
B-HALF
A-MODE
B-MODE
REC (FWD)
REC (REV)
CX-JN10
BLOCK DIAGRAM – AMP/POWER SUPPLY Section –
(EXCEPT AEP, UK)
MIC LEVEL
AGC
Q401
(EXCEPT AEP, UK)
VR401
MIC MIXING
J401
MIC
MIC AMP
IC401 (1/2)
(Page 21)
H
MIC AMP
IC401 (2/2)
F
–VH
OUTPUT LEVEL
DETECT
Q235
R-CH
+VL
L
CURRENT
MIRROR
Q105, 107
R-CH
CD
–VL
(AEP, UK)
PB, REC
+VP
21 B-IN
PB-OUT 6
TU
+
7 VOL-IN
PRE DRIVE
Q101, 103
OUT 18
23 C-IN
PB
2 PB1P
REC
CASCADE
Q109 (AEP, UK)
Q109, 111 (EXCEPT AEP, UK)
MUTING
Q181
CONT
(Page 21)
28 REC1O
INPUT SELECT,
ELECTRICAL VOLUME
IC601
J221
PHONES
FINAL DRIVE
Q121, 123
R-CH
BIAS
Q117, 119
R-CH
R-CH
MUTING
CONTROL
Q183
13
OVER LOAD
DETECT
Q129
OVER CURRENT
DETECT
Q281
+
TH101, 102
+
THERMAL DETECT
Q291, 292
+
R-CH
DC DETECT
Q063, 064
HOLD
Q282
+
LM-L
LM-R
TM-L
TM-R
14
15
12
13
LM-L
LM-R
TM-L
TM-R
HOLD
Q045, 046
LOADING/TABLE
MOTOR DRIVE
IC672
POWER
S-OUT
CLK
LCK
DATA
DATA, CLK,
S-OUT, LCK
J203
SPEAKER
PROTECT
Q047
+
–
L
+
–
R
MUTE, POWER,
HOLD
B
(Page 20)
POWER
MUTE
G
VH1, 2 (AC)
VH1, 2 (AC)
AC DETECT
D067, 068
+
2 3 4
(Page 21)
(EXCEPT AEP, UK)
HOLD
D
+
LM-L, LM-R,
TM-L, TM-R
DATA
CLK
LCK
(Page 20)
R-CH
+VL
19 A-IN
E
+
–VL
R
(Page 21)
OUTPUT LEVEL
DETECT
Q233, 234
SWITCHING
Q232
MIC
J602
A
+VH
R-CH
D402
VIDEO/AUX
(Page 20)
SWITCHING
Q231
–VP
6-3.
VDD
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
: CD PLAY
: TUNER (FM/AM)
: TAPE PLAY (DECK-A)
• Abbreviation
AUS : Australian model
E51 : Chilean and Peruvian models
EA : Sausi Arabia model
SP : Singapore model
TW : Taiwan model
+9V
REGULATOR
IC002
VM
+3.3V (CD)
+6.4V (CD)
+4V
REGULATOR
IC003
+4V
(EXCEPT AEP, UK)
D691 – 694
D697
+9V
REGULATOR
IC001
CD-VM
(EXCEPT AEP, UK)
: REC
VCC
B+ SWITCH
Q023, 024
+VH
: AUX IN
TO
POWER AMP
BLOCK
: MIC INPUT
–VH
VSS
(Page 20)
C
RESET
RESET SWITCH
Q901
TO
FLUORESCENT
INDICATOR TUBE
RESET SIGNAL
GENERATOR
IC502
D504
+3.3V
VDD (STBY)
STANDBY
SWITCH
Q902, 903
POWER TRANSFORMER
(SUB)
PT002 (E, EA, E51, SP, TW)
PT011 (AEP, UK, AUS)
+4V
REGULATOR
IC501
V-STBY
RECT
D015 – 018
VM1
VM2
VH1
VH2
VL1
VL2
(EXCEPT AEP, UK)
VF1
(E, EA, E51, SP)
VF2
S001
VOLTAGE SELECTOR
–VFL
P-DOWN
(AEP, UK)
RECT
D009
(AEP, UK)
+VL
–VL
RESET,
P-DOWN
RECT
D019, 020 (AEP, UK)
D019 – 022 (EXCEPT AEP, UK)
–27V REGULATOR
Q043 (AEP, UK)
Q041, 043 (EXCEPT AEP, UK)
POWER TRANSFORMER
(MAIN)
PT002 (AEP, UK, AUS)
PT004 (E, EA, E51, SP, TW)
RY001
RELAY DRIVE
Q022
110 – 120V
220 – 240V
(AC IN)
RECT
D091, 092
(AEP, UK, TW, AUS)
22
22
CX-JN10
6-4.
• Circuit Boards Location
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
: Pattern from the side which enables seeing.
•
(The other layers' patterns are not indicated.)
• Indication of transistor.
C
Q
These are omitted.
B E
Q
B C
E
These are omitted.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
SENSOR board
PT board
BD board
SW board
MOTOR (TB) board
MOTOR (LD) board
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
CD KEY board
TUNER PACK
PANEL board
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
– BD Section –
no mark : CD PLAY
– Other Sections –
no mark : FM
: Impossible to measure
∗
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : TUNER (FM/AM)
E : TAPE PLAY (DECK-A)
d : TAPE PLAY (DECK-B)
G : REC
J : CD PLAY
L : AUX IN
N : MIC INPUT
• Abbreviation
AUS : Australian model
E51 : Chilean and Peluvian models
EA
: Saudi Arabia model
SP
: Singapore model
TW : Taiwan model
DRIVER board
HP board
KEY board
23
23
MAIN board
CX-JN10
6-5.
PRINTED WIRING BOARD – BD Section – • See page 23 for Circuit Boards Location.
:Uses unleaded solder.
+
M702
(SPINDLE)
BD BOARD
M
S701
(LIMIT IN)
−
+
16
14
2
15
1
1
IC722
OPTICAL
PICK-UP
BLOCK
(KSM-213DCP)
15
M701
(SLED)
M
28
ECB
−
CN710
1
2
TP
(VC)
TP (FE)
TP
(RF)
TP (TE)
C952
(AEP, UK)
1
A
80
MAIN
BOARD
CN691
(Page 32)
20
IC721
21
61
18
19
60
14
1-688-816-
40
C951
(SHIELD CASE)
24
24
(AEP, UK)
41
(14)
CX-JN10
R729
12k
C744
1
C754
47p
R726
680
R725
680
AUTOMATIC
POWER
C703
0.1
E
R711
330
R702
15k
D
R703 15k
B
R704 15k
C
R705 15k
F
R701 47k
GND
R706 47k
CL
CE
CL
DI
DO
DATA
EFMIN
LRSY
R751 47k
TP (RF)
RF
ASDFIN
R752 47k
16MOUT
FIN2
EFLG
TIN1
C2F
TIN2
XVSS
VREF
CD DSP
REF1
IC721
LC78646E-E
C716 0.001
F+
C717
T-
C718 1
T+
C719
R754
47k
FSX/16MIN
R765 1M
R713 1k
FE
XOUT
TEC
XVDD
TE
RVDD
RFMON
RCHO
JITTC
RVSS
ADAVDD
LVSS
FB701
0.0047
X701
16.9344MHz
C735 18p
TP (TE)
0.0047
R741 0
R739 0
R740 6.8k
0.01
R715
100
DOUT
VDD
VSS
MONI5
MONI4
MONI3
MONI2
MONI1
FSEQ
R714
100
C729
220
10V
(AEP,UK)
C706
0.1
0.01
C732
LVDD
TEST
R738
6.8k
C702
100
10V
C733
LCHO
V/*P
CONT4
C701
0.1
SLDO
FDO
SPDO
TDO
GPDAC
ADAVSS
MP3RES
C721 0.1
SBCK/FG
C720 100p
F-
C734 15p
XIN
TP (FE)
C715 1 50V
R745 100
DEFECT
PD
ASLRCK
FIN1
SBCK/CONT6
(LD)
RFVSS
TP (VC)
R760
100
R747
33
C951
0.1
C756
47p
C722
0.1
R746
33
C707
100
10V
M701
CN710
19P
(SLED)
CD_CE
DRF
OP
IN(-)
OP OUT
VO3(-)
VO3(+)
RESET
GND
VO2(-)
FOIN
VO2(+)
TIN
VCC
VCC
IN3
IN2
GND
MUTE
SLIN
IN4
BIAS
REGOUT
REG-B
RESET
IC722
BA5836FP
VO1(+)
COIL DRIVE
SPIN
GND
VO4(-)
SLED/SPINDLE
MOTOR DRIVE,
FOCUS/TRACKING
VO4(+)
CD_WRQ
VO1(-)
(PD)
ASDACK
R753 47k
LD
VR
C751
47p
DATACK
RFVDD
A
CD_CE
DI
CD_WRQ
*WRQ
DRF
VSS
VDD5
CONT2
PDO1
VVSS
PDO2
SLCIST
LIMIT SW
C712
47p
PCKIST
FR
SLCO
C714
0.1
VVDD
CN708
16P
VCC
C750
47p
R708
10k
LDD
C710
0.047
C745
47p
R728
47k
CD_MUTE
NC
C711
0.1
R722
100
R727
100
S701
R709
27k
VC
B
R730
1.2k
(LIMIT IN)
C713
0.0047
E
D
VC
VCC
A
F
GND
C723
100
10V
R721
100
C741
0.1
C704
47
10V
CONTROL
LDS
C705
0.001
R720 100
C708
0.1
C742
0.1
R719 100
C746
0.1
R717 100
C709
100
10V
Q701
KTN2907AS
-RTK
C753
47p
R716 100
R707
10
C752
47p
C743
0.047
R731
2.2k
R718 100
DRF
R732
0
DO
• See page 42 for Waveforms.
CD_RES
• See page 42 for IC Block Diagram.
*RES
SCHEMATIC DIAGRAM – BD Section –
C
6-6.
CL
DO
DO
CD_RES
FB707
DRF
WRQ
CL
DI
FB708
CD_CE
DI
CD_RES
CD_ON
CD-R
A-GND
M702
CD-L
(SPINDLE)
(Page 31)
(AEP,UK)
3.3V
C952
0.1
R744
100k
D-OUT
AMUTE
D-GND
C747
0.1
C748
220
10V
6.4V
P-GND
25
25
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-JN10
PRINTED WIRING BOARDS – CHANGER Section – • See page 23 for Circuit Boards Location.
SENSOR BOARD
A
:Uses unleaded solder.
SW BOARD
K
CN751
S751
OPEN/CLOSE
DETECT
(Page 32)
DRIVER BOARD
CN701
CN702
R732
3
JW708
R734
R735
1
IC712
9
1
IC701
9
JW709
C741
CN741
JW706
JW711
MOTOR (TB) BOARD
JW707
(12)
R733
1-687-669-
C731
C752
JW712
2
1
12
12
R751
CN705
(12)
JW701
R711
R712
R721
R722
JW710
R723
C737
CN742
C736
R713
M741
(TABLE)
C735
D711
M
R701
D701
R702
C751
CN703
(12)
CN704
2
1
4
JW714
12
1-687-134-
JW713
1
C715
Q731
E
JW704
OPEN
JW705
CLOSE
CN731
MAIN BOARD
CN692
B
R731
C
JW702
E
1
2
JW703
IC731
1-687-132-
6-7.
12
1-687-135-
MOTOR (LD) BOARD
S711
ROTARY ENCODER
DISC TRAY
ADDRESS DETECT
M751
(LOADING)
M
CN721
2
1
12
1-687-133-
26
(12)
26
(12)
CX-JN10
FIN
GND
RIN
FIN
GND
RIN
VM
VCC
VM
VCC
RNF
OUT1
OUT1
DRIVE
OUT2
VREF
LOADING MOTOR
RNF
SCHEMATIC DIAGRAM – CHANGER Section – • See page 42 for IC Block Diagrams.
IC701
BA6956AN
CN721
2P
M751
R702
100
CN704
2P
LM-2
LM-2
LM-1
LM-1
C751
0.01
(LOADING)
R701
470
D701
MTZJ-T-77
5.1A
S711
TABLE MOTOR
CN703
4P
E3
E-3
E2
E-2
E1
E-1
VREF
ADDRESS DETECT
DRIVE
OUT2
DISC TRAY
IC712
BA6956AN
R721 4.7k
R723 4.7k
R722 4.7k
C737 0.1
C735 0.1
GND
C736 0.1
6-8.
R712
4.7k
D711
MTZJ-T-77
3.6B
M741
(TABLE)
CN731
3P
SENS-IN
IC731
RPI-576
SENS-OUT
GND
CN742
5P
CN741
3P
SENS-IN
TM-2
TM-1
TM-1
GND
SENS-OUT
GND
C715
100
16V
CN701
12P
CD-VM
R713
22k
GND
CN702
5P
TM-2
SENS-IN
SENS-OUT
R711
1k
LM-R
LM-L
C741
0.01
TM-R
TM-L
SENS-IN
SENS-OUT
GND
E-1
R735
100
E-2
E-3
TBL ADDRESS SENS
3.3V
R734
12k
R732
10k
OPEN SW
R731
100
TABLE ADDRESS SENSOR
R733
1k
S751
OPEN/CLOSE
DETECT
OPEN
CN751
2P
OPEN SW
GND
Q731
DTC114ESA
CN705
2P
LEVEL
OPEN SW
SHIFT
GND
C731
10
50V
C752
0.1
CLOSE
27
27
R751
4.7k
(Page 31)
CX-JN10
6-9.
SCHEMATIC DIAGRAM – MAIN Section (1/4) –
(1/4)
R017
(EXCEPT AEP,UK)
VM(AC)
(AUS)
0.22
(AEP,UK)
0.33
(EXCEPT AEP,UK)
D019
EGP20D
VM(AC)
C007
VH(AC)
D021
EGP20D
D020
EGP20D
D022
EGP20D
3300 25V (AEP,UK)
3300 35V (EXCEPT AEP,UK)
A1
VH(AC)
C011 C012 C033
0.1
0.1
0.1
(AEP,UK)
VL(AC)
(Page 39)
A2
JW001
∗ R028
VL(AC)
390 (AEP,UK)
JW002
330 (EXCEPT AEP,UK)
GND(M)
A5
VCC
Q023
2SA1015
D031
1SS355
(EXCEPT AEP,UK)
D016
1N5402
D017
1N5402
D018
1N5402
R031
10k
GND(M)
FIL-1
+9V REGULATOR
FIL-2
+9V REGULATOR
+4V REGULATOR
IC001
TA7809
IC002
TA7809
IC003
TA7804LS
I
I
O
G
I
G
Q023,024
B+ SWITCH
R036
18k
C030
0.0047
O
Q024
2SC3052
G
D033
1SS355
C005
P-ON
∗
VSTBY
C017
0.1
C018
0.1
C006
∗
∗ C005,006
JW004
(Page 29)
Q022
2SC3052
3300 25V (AEP,UK)
3300 35V (EXCEPT AEP,UK)
C015 C016
0.1
0.1
RELAY
(AEP,UK)
C023
100
35V
JW005
C022
100
16V
C026
47
25V
D023
11EQS04
DRIVE
C029
47
10V
C035
0.1
C031
47
25V
R032
47k
C032
33
25V
R035
8.2k
R001 ∗
(AEP,UK)
R002 1.8
C008
1000
25V
F1
R092
100
R093
15k
C062
1
50V
C063
1
50V
R094
10k
R004 ∗
R096
33k
Q045
2SC3052
(EXCEPT AEP,UK)
∗ R001,004,005,008
1.8
(AEP,UK,AUS)
3.3
(EXCEPT AEP,UK,AUS)
R068
68k
∗
D041
10EDB40
R007
1.8
(AEP,UK)
R041
100k
R042
100k
D042
10EDB40
D043
10EDB40
R051
100k
D045
UDZSTE-1727B
R097
33k
R095
15k
R070 27k
C045
100
50V
F2
Q047
2SC3052
PROTECT
HOLD
R071 27k
R005
Q046
2SC3052
Q045,046
R067
68k
R075
5.6k
R074
27k
R073
27k
∗ R078,079
0 (AEP,UK)
C046
100
50V
R047
0 (AEP,UK)
R046
4.7k
R048
0
4.7k (EXCEPT AEP,UK)
R049
4.7k
D066
1SS355
C047
100
10V
12k (EXCEPT AEP,UK)
A8
R008
∗
(EXCEPT AEP,UK)
C042
∗
D063
MC2836
Q041,043
C044
-27V REGULATOR
(EXCEPT AEP,UK)
R076
1k
R077
1k
R044
100k
C061
47
25V
R038
0
R045
0 (AEP,UK)
R037 0
150 (EXCEPT AEP,UK)
Q043
2SA1015
R050
10
R069
10k
R072
5.6k
Q063
2SA1235
Q063,064
DC DETECT
Q064
2SC3052
R080
100k
10 50V (EXCEPT AEP,UK)
VH1
(AEP,UK)
VH2
VH2
∗
D069
1SS355
D044
10EDB40
VH2
VH1
VH1
∗ C041-044
100 35V (AEP,UK)
R079
R085 56k
∗
Q041
2SA1015
R043
100k
∗
R083 33k
∗
D068
MC2836
D067
MC2838
R078
R087 10k
C043
D064
MC2838
D065
1SS355
R084 56k
∗
R082 33k
C041
R086 10k
(Page 39)
O
R033 68k
D015
1N5402
HOLD
V-STBY
4V
-VFL
VDD
VM
CD-VM
R024
270
D032 1SS355
JW006
JW003
O-POWER
R014 18k
R013 18k
R016 18k
R015 18k
A6
JW023
JR002
0
(AEP,UK)
∗
R030
390
R025
270
WH011
7P
VL(AC)
R029
390
C034
0.1
WH013
11P
VL(AC)
R028
R027
390
VSS
R026
390
3300 50V
C014
0.1
A4
C004
C013
0.1
VSTBY
R010 18k
P-ON
R009 18k
R012 18k
(Page 41)
(EXCEPT AEP,UK,AUS)
R011 18k
D009
D5SBA20
FIL-2
C003 3300 50V
A3
FIL-1
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
28
28
CX-JN10
6-10. SCHEMATIC DIAGRAM – MAIN Section (2/4) –
R123
6.8k
D107
MC2838
R131
4.7k
Q101,103
PRE DRIVE
(AEP,UK)
(2/4)
R119 2.2k
Q103
2SA1235
OUT-L
C113 33 50V
5.6k (EXCEPT AEP,UK)
Q101
2SA1235
C111
100p
∗
D109 AU-01Z
C115
820p
∗ R115,116
VDD
F2
HOLD
Q107
2SC3052
27k (EXCEPT AEP,UK)
O-MUTE
C131
100p
Q181
2SD1306
NE
R182
12k
Q183
2SA1235
CD-D-GND
MUTING
FR-A-GND
1.8k
(EXCEPT AEP,UK)
R141
∗
Q182
2SD1306
NE
R122
1k
Q110
2SD814A
CASCADE
Q102
2SA1235
C116 R126
820p 1.5k
C106
2.2
50V
R110
100
∗
D104
1SS355
C112
100p
Q108
2SC3052
∗
R116
R128
100
2SB1677
(EXCEPT AEP,UK)
C126
0.01
R159
1k
Q130
R154
R160
1k
∗
∗
OVER LOAD
R156
∗
DETECT
R150
0.22
3W
∗ Q155,156
R148
0
(Page 33)
(AEP,UK)
R152
0.22
3W
C122
0.1
L OUT
∗ Q121,122
2SB1342
Q120
2SC3052
BIAS
C120
0
1.2k
(AEP,UK)
1.5k
(EXCEPT AEP,UK)
Q122
CASCADE
∗ R143,144
R142
R144
27 (AEP,UK)
∗
∗
1k (EXCEPT AEP,UK)
JW201
∗ L201,202
Q112
2SC2909
47k (AEP,UK)
R130
100
(EXCEPT AEP,UK)
R158
100
Q118,120
R138
2.2k
∗ R141,142
MIRROR
∗
2SB792A
Q118
2SC3052
C120
100p
100V
L-IN
(AEP,UK)
∗
39 (EXCEPT AEP,UK)
A2
∗
C136
0
FINAL DRIVE
C130
100p
100V
L202
1,7µH (AEP,UK)
1µH (EXCEPT AEP,UK)
L201
R201
10
∗
∗
R280
10k
VCC
C201
0.1
Q281
A3
C230
10
63V
C281
0.0047
R237
1k
A4
A5
(CHASSIS)
R-IN
∗ Q129,130
2SA1235
Q124
(EXCETP AEP,UK)
Q106,108
CURRENT
C110
10
50V
A1
HOLD
EP099
WH201
5P
FINAL DRIVE
R140
(AEP,UK)
R114
1.2k
C134
0
R134
*
(AEP,UK)
C118
Q106
2SC3052
R189
0
22K (EXCEPT AEP,UK)
(CHASSIS)
C097
0.1
D108
MC2838
C128
100p
100V
D110
AU-01Z
R188
C241
0.47
R162
6.8k
R-OUT
Q104
2SA1235
15k (AEP,UK)
R163
5.6k
GND
Q102,104
JR104
0
R161
6.8k
R118
2.2k
C114
33
50V
R106
15k
C182
0.33
50V
∗
FINAL DRIVE
C129
100p
100V
R132 4.7k
∗
R120
2.2k
R185
68k
R184
∗
(AEP,UK)
Q121
R143
∗
∗
DETECT
(AEP,UK)
C135
0
47k (EXCEPT AEP,UK)
∗
R149
0.22
3W
CASCADE
PRE DRIVE
R186
47k
(AEP,UK)
D106
MC2836
MUTING
CONTROL
R129
100
Q129
R155
OVER LOAD
2.2k
Q111
2SC2909
∗ R139,140
MIRROR
R127
100
R108
SP-A-GND
R157
100
C125
0.01
∗
R151
0.22
3W
∗ R133,134
R124
6.8k
R181
12k
CD-P-GND
R153
R147
0
(AEP,UK)
(EXCEPT AEP,UK)
0 (AEP,UK)
MUTING
C132
100p
CURRENT
∗
C109
10
50V
C104
O-MUTE
FUNC-A-GND
R105
15k
R115
R113
1.2k
∗
V-STBY
V-STBY
CD-A-GND
∗
∗
C103
(AEP,UK)
O-MUTE
R107
O-POWER
100P 50V
100P 100V
Q105,107
D101
MC2836
-VFL
-VFL
O-POWER
FR-D-GND
CASCADE
22k (AEP,UK)
VM
VM
Q109
2SD814A
Q105
2SC3052
∗ R107,108
HOLD
TU/AUX-A-GND
D103
1SS355
27k (EXCEPT AEP,UK)
F2
Q231
2SK2937
D231
1SS355
SWITCHING
S
R282
12k
∗
C203
0.1
OVER CURRENT
DETECT
R236
2.2M
R241
3.3k
R281
2.2k
R242
10k
R203
10
D281
MC2838
Q282
R204
10
HOLD
C204
0.1
R283
A6
C232
0.1
R238
2.2k
D239
UDZS-175.6B
D235
D235
RK46
12k (E51,MX)
Q233
2SA1235
R239
2.2k
R252
10k
R257
47k
R258
47k
R261
4.7k
OUTPUT LEVEL
DETECT
R246
4.7k
2SC3052
(AEP,UK)
2SD814A
(EXCEPT AEP,UK)
∗ Q281,292
Q233-235
D241
1SS355
C202
0.1
∗ Q282
R262
4.7k
Q234
2SC3052
D242
0
∗
10k (EXCEPT E51,MX)
D243
MC2838
C282
0.0022
D232
UDZS-1710B
(AEP,UK)
C205
0.01
J203
4P
+
C209
0
L
-
2SA1235
(AEP,UK)
2SB792A
(EXCEPT AEP,UK)
SPEAKER
C206
0.01
+
R
C210
0
-
R284
4.7k
R248
4.7k
(AEP,UK)
(Page 28)
D236
RK46
R249
4.7k
R250
4.7k
R260
47k
R263
4.7k
R264
4.7k
R253
10k
D240
UDZS-175.6B
JW232
D244
MC2836
C207
0.01
C208
0.01
(CHASSIS)
R290
47k
R291
2.2k
D236
(AEP,UK)
TH102
TH101
JW231
R259
47k
R293
R294
∗
∗
R295
22k
R297
47k
EP001
R296
47k (AEP,UK)
(CHASSIS)
SWITCHING
S
Q235
2SA1235F
R243
1k
Q291
DTA114EKA
Q291,292
Q292
∗
R292
10k
D292
MC2838
C231
10
63V
(EXCEPT AEP,UK)
R244
2.2k
Q232
2SK2937
D291
MC2836
(Page 30)
R125
1.5k
22k (AEP,UK)
F1
F1
(EXCEPT AEP,UK)
BIAS
(EXCETP AEP,UK)
∗ C117,118
VSS
VDD
(AEP,UK)
3.3k
(AEP,UK)
(EXCEPT AEP,UK)
5.6k
JW202
(AEP,UK)
820p
Q119
2SC3052
R202 10
680p
(EXCEPT AEP,UK)
R641 5.6k
VSS
R139 *
4V
4V
(AEP,UK)
2SD1619
Q117,119
∗ C103,104
CD-VM
∗ Q123,124
2SD1933
∗ Q153,154
C119
100p
100V
C117
(AEP,UK)
(EXCETP AEP,UK)
CD-VM
R137
2.2k
(EXCETP AEP,UK)
OUT-R
∗
C121
0.1
D111
MC2838
∗ R183,184
6.8k (AEP,UK)
C119
0
Q117
2SC3052
(EXCEPT AEP,UK)
R109
100
∗
(AEP,UK)
∗
Q123
FINAL DRIVE
R133
(AEP,UK)
D105
MC2836
C127
100p 100V
(AEP,UK)
R183
R121
1k
R117
2.2k
C105
2.2
50V
C181
0.33
50V
C133
0
THERMAL DETECT
∗ R293,294
220k
(AEP,UK)
68k (EXCEPT AEP,UK)
A8
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
29
29
CX-JN10
• See page 42 for IC Block Diagram.
6-11. SCHEMATIC DIAGRAM – MAIN Section (3/4) –
• See page 42 for Waveforms.
(3/4)
SP-A-GND
C687 0.01
TU/AUX-A-GND
B3
CD-A-GND
B4
FR-A-GND
FUNC-A-GND
CD-D-GND
B5
CD-P-GND
B6
FR-D-GND
CD-VM
B7
CD-VM
4V
4V
VSS
TP601
VSS
VDD
R
VDD
G
L
(AEP,UK)
F1
F1
JR601
0
F2
(Page 29)
F2
R653
22k
JR611
0
HOLD
HOLD
~~~~
~~~
VM
B8
VM
R654
22k
-VFL
-VFL
(AEP,UK)
O-POWER
O-POWER
O-MUTE
O-MUTE
R655
22k
R645
4.7k
R656
22k
R612
4.7k
C734
0.1
C733
0.1
VDD
V-STBY
V-STBY
OUT-L
OUT-L
OUT-R
B11
OUT-R
STEREO
C610
1 50V
C609
1 50V
R607
100k
R603
390k
R605
1.2k
R601
100
STEREO
TUNED
R652
100
TUNER TUNE
PLL-CE
R610
18k
C608
470p
R606
1.2k
C604
100
10V
R608
100k
DATA
VSS
C601
47p
R651
100
CLK
RDS-DATA
(Page 31)
R663
10k
R661
15k
D663
1SS355
C612
560p
C602
47p
IFC
C662
47
25V
R602
100
DATA
CLK
C664
0.1
R604
390k
PLL-CE
IFC
C661
220
10V
C663
0.1
DATA
TU-MUTE
TU-MUTE
R609
18k
D662
UDZS-174.7B
C614 0.0033
VF1
C607
470p
C603
100
10V
C613 0.0033
F1
C611
560p
RDS-SIG
TU-SIG
FB601
0
C606
0.0068
F2
VF2
C605
0.0068
R657
56k
-VFL
-VFL
(EXCEPT AEP,UK)
D661
UDZS-174.7B
CN601
30P
R662
47k
RDS-DATA
RDS-CLK
RDS-CLK
V-STBY
V-STBY(EVER)
HOLD
HOLD
4V
VEE
CONT
VDD
TRE1(R)
VOLUME
BASS(R)
OUT(R)
OUT(L)
INPUT SELECT,
ELECTRICAL
BASS(L)
GND
VOL-IN(R)
VOL-IN(L)
PB-OUT(L)
TRE1(L)
A-IN(L)
O-POWER
O-POWER
A-IN(R)
O-MUTE
B-IN(L)
O-MUTE
C-IN(L)
CD-VM
B-IN(R)
CD-VM
C-IN(R)
PB-OUT(R)
STB
STB-I/O
REC1O(R)
PB2N(R)
D-GND
PB1P(L)
REC1O(L) PB1N(L)
(Page 35)
REC1N(L)
TBL-SENS
CD-NUMBER SENS
REC1N(R)
PB2P(R)
+4V
IC601
BD3881FV
BU-UP
BU-UP/DOWN SW
SPEANA
VF-ON
S-OUT
S-0UT
PB2
R658
22k
JR610
1K
PB2
O-BIAS
O-BIAS
B13
MIC-OUT
A-GND
JR609
1K
C301 0.0012
S
Q301
2SJ460
R301 39k
HP1
(PB)
C621
180p
R631
470
S
Q303
2SK2541
C622 180p
R627
2.2k
R628
2.2k
R629
10k
R630
10k
C643
0.22
50V
R632
470
C641
0.22
50V
C644
0.22
50V
R643
3.3k
R620 27k
TU-R
R619 27k
TU-L
C642
0.22
50V
B15
R644
3.3k
Q302
2SJ460
C303
0.0012
R638 330
R636 1.2k
AUX-R
R615 15k
AUX-L
R622 5.6k
R623 3.9k
R624 3.9k
R625 ∗
∗ R625,626
C306
0.001
3.9k
(AEP,UK)
3.3k
(EXCEPT AEP,UK)
OUT-R
R621
5.6k
S
R305
220k
S
Q307
2SK2541
R303
82k
S
D301
MC2836
Q308
2SK2541
Q307-309
CD-VM
Q601
DTA114EKA
MUTING
(DECK-B)
INVERTER
PB2
CN302
8P
R CH
R311
10k
C321
0.1
C311
1000p
C312
1000p
Q311
2SA1015
Q310
2SC2001
R659
2.2k
C316
0.015
R313
27k
BIAS OSC
C317
0.015
R317
1k
R315
39
L311
BIAS OSC
C322
0.1
C313
470p
R312
10k
C318
0.0047
C314
470p
L CH
ERASE
CD-L
R616 15k
OUT-L
FB602
0
R626 ∗
S
C624 5600p
Q306
2SJ460
MUTING
C626 8200p
Q305,306
C305
470p
Q309
2SK2541
C304
0.0012
Q305
2SJ460
R634 3.3k
S
R633 3.3k
C625 8200p
S
(REC/PB/ERASE)
R617 15k
Q301-304
PB SWITCH
R304
82k
CD-R
R618 15k
S
R CH
HRPE1
R635 1.2k
R637 330
Q304
2SK2541
C623 5600p
CN301
3P
L CH
R302 39k
C302 0.0012
(DECK-A)
C315
0.022
30
30
R314
10
C319
10
50V
Q311,312
REC BIAS
SWITCH
Q312
2SC3052
R316
10k
R318
4.7k
C320
0.1
O-BIAS
CX-JN10
6-12. SCHEMATIC DIAGRAM – MAIN Section (4/4) –
• See page 42 for IC Block Diagram.
(EXCEPT AEP,UK)
(4/4)
RDS-CLK
CN801
11P
RDS-DATA
B3
B4
CLK
(AEP,UK)
CL
IFC
C912
100p
C911
100p
DO
DATA
FM 75Ω
DI
(COAXIAL)
PLL-CE
B5
TUNER PACK
CE
VM
B6
SUPPLIED WITH
+9V
THE ASSEMBLED
TUNED
B7
TUNED
BLOCK
STEREO
B8
STEREO
TU-L
L-CH
AM LOOP
GND
TU-R
R-CH
TU-MUTE
MUTE
R801
220
CN802
15P
DO
CE
(AEP,UK)
+9V
C913
1000p
(AEP,UK)
C801 10 50V
DI
C802 0.1
D801 UDZS-175.1B
R810 1k
R807 1k
R812 0
R809 0
CL
TUNED
STEREO
L-CH
GND
(EXCEPT AEP,UK)
R-CH
JR801
0
(Page 30)
MUTE
5V
RDS-SIG
FM-SOUT
RDS INT
RDS DATA
R685
3.9k
AUX-L
C699
0.01
C685
1000p
(AEP,UK)
L
J602
2P
VIDEO/AUX
C698
0.01
AUX-R
R
R686
3.9k
C686
1000p
C910
0.01
(AEP,UK)
(AEP,UK)
B11
(AEP,UK)
FB693 C695
0.45µH 470
D691
D692
10EDB40 10EDB40
CD-VM
D693
10EDB40
CN691 19P
D694
10EDB40
(CHASSIS)
P-GND
6.4V
JW692
D-GND
AMUTE
D697
10EDB40
B13
D024
4V
D-OUT
3.3V
CD-L
C693 1 50V
CD-L
FB691
A-GND
CD-R
C694 1 50V
B15
CD-R
Z1
CD_ON
Z2
4V
LOADING/TABLE
C731
100p
CL
Z6
C653
330p
R702
10k
R703
10k
R704
10k
R705
10k
C652
1000p
R730 10k
OE
WRQ
DRF
CD_CE
C651
1000p
R731 10k
BBE
CLK
STB
FSYNC
Z9
Z10
DATA
CLK
MP3_CE
Z7
Z8
VSS
S-OUT
Z5
VM
C684
0.1
VDD
CN694 11P
Z1
R732 10k
CD_ON
LM-R
LCK
D-GND
C950
330p
LM-L
FREQ1
DI
Z5
TM-L
CL
FREQ3
Z6
MP3_CE
BOOST4
Z7
BOOST1
FSYNC
R737 47k
R735 47k
R736 47k
(Page 35)
Z8
BOOST3
R733 47k
CD_RES
Z4
Z3
FREQ2
R734 47k
Z2
DO
TM-R
JW690
10EDB40
(Page 25)
DI
DO
C654
100p
D671
1SS355
C730
100p
IC672
BU2092F
CD_RES
Z3
Z4
MOTOR DRIVE
C732
100p
C655
330p
WRQ
BOOST2
D695
1SS355
4V
Z9
DRF
Z10
CD_CE
R738
47k
R739
47k
CN692 12P
VM
CD-VM
CD-VM
GND
LM-R
TBL-SENS
LM-L
BU-UP
TM-R
R692 10k
R693 1k
R691
22k
TM-L
E-1
R695 10k
R696 1k
R694
22k
E-2
E-3
R701
22k
R698 10k
R699 1k
R697
22k
TBL ADDRESS SENS
3.3V
R700
22k
31
31
OPEN SW
(Page 27)
CX-JN10
6-13. PRINTED WIRING BOARD – MAIN Section – • See page 23 for Circuit Boards Location.
1
2
3
4
5
:Uses unleaded solder.
6
7
8
9
10
11
12
13
MAIN BOARD
A
R807
JW662
C802
JW644
JW809
JW643
D663
D693
JW020
JW052
JW094
JW006
JW027
JW028
D020
D022
D019
JW095
C018
JW096
JW010
(AEP, UK)
JW098
JW097
C013
C014
C034
JW053
C015
C016
C033
C012
JW033
JW205
C004
R011
R012 JW031
JW032
JW034
R010
JW048
JW074
JW049
C203
C201
C006
R203
R009
C026
JW015
JW012
JW016
JW013
C205
JW024
C023
D023
JW025
C029
JW085
D235
JW213
C209
JW088
C022
JW099
+
(AEP, UK)
L
JW089
C207
C003
R
C005
JR002
JW706
(EXCEPT AEP, UK)
C204
(AEP, UK)
L201
I
1-688-398(CHASSIS)
32
–
R204
C202
32
SPEAKER
+
C208
JW057
JW023
J203
(AEP, UK)
R201
E
JW207
3
EP001
C206
1
JW071
3
JW035
1
IC001
JW206
–
JW086
C210
(AEP, UK)
JW047
L202
(AEP, UK)
R159 R163
R013
JW045
JW046
(EXCEPT AEP, UK)
R155
TH101
(EXCEPT AEP, UK)
R014
JW056
IC002
R157
JW040
JW036
K
(EXCEPT AEP, UK)
JW050
JW083
(AEP, UK)
3
C125
R161
E
R189
JW039
JW101
A
D111
C
R015
R036
D033
R245
R236
R153
B
C687
C698
R016
JW038
D031
Q123
E
JW090
Q119
Q023
C230
1
JW102
Q121
C032
C035
JW217
Q117
L
C011
G
(EXCEPT AEP, UK)
E
J602
VIDEO/AUX
(AEP, UK)
(EXCEPT AEP, UK)
JW210
R237
JW211
D
JW103
E
R685
C685
D018
C231
IC003
R242
R147
C686
D009
C007
JW067
S
D241
R137
JW105
E
R244
JW231
JW212
D235
Q231
D232
R
R686
JW005
C017
(AEP, UK)
JW055
JW009
Q045
E
(EXCEPT AEP, UK)
D236
R249
(AEP, UK)
R151
R149
C121
A
EXCEPT
AEP, UK
JW026
R031
C030
JW059
JW041
JW042
D021
JW003
(EXCEPT AEP, UK)
JW051
Q129
C
(AEP, UK)
JW072
R035
D231
JW104
B
(AEP, UK)
JW007
(JN30)
C062
E
C910
JW008
R094
R097
JW060
JW061
JW064
JW062
JW063
JW065
JW066
JW068
JW037
JW232
D236
R239
C232
R238
R248
R257
R246
E
Q111
R162
R096
JW029
(EXCEPT AEP, UK)
JW069
JW070
S
D
R243
R069
R068
R067
JW078
JW076
JW077
R075
R074
R250
(AEP, UK)
R160
R084
Q047
R092
D032
R033
(AEP, UK)
R241
C127
C134
C128
(AEP, UK)
R164
R158
D240
(AEP, UK)
E
JW134
E
Q234
C129 JW106
C135
E
JW693
JW648
R705
R704
JW092
JW091
R072
R258
EXCEPT
AEP, UK
R156
JW108
C
R080
Q235
R073
JW215
R141
R005
D044
D042
R042
C042
D691
JR616
JW080
JW079
JW082
R071
R070
JR201
C111
R131
R123
E
Q130
B
R085
E
Q024
(AEP, UK)
R079
JW114
JW113
C136
C130
C117
E
Q109
R154
E
Q107
R139
Q124
R253
Q233
E
C126
E
JW093
Q232
E
R143
R125
JW110
TH102
(AEP, UK)
(CHASSIS)
JW019
D017
Q063
R076
R078
D242
E
D109
C119
Q120
R134
E
C115
D103
E
Q122
C
W004
R083
C031
(EXCEPT AEP, UK)
(EXCEPT AEP, UK)
7
WH012
D015
C061
(EXCEPT AEP, UK)
R252
K
Q105
E
1
R093
E
R077
K
D239
D243
11
R082
C063
Q064
D064
C133
R138
D066
R133
E
Q118
B
R113
R115
A
R148
K
A A
D065
A A
R127
C113
EP099
(CHASSIS)
D043
D041
JW651
JW689
R736
C131
R294
R117
JW109
R119
Q112
C122
R129
Q101
R121
D105
JW111
JW112
(AEP, UK)
R087
R095
G
E
Q103
K K
(EXCEPT AEP, UK)
K
JW075
D069
R152
K
R109
K
R142
E
Q110
JW116
JW665
JW666
JW697
JW698
C732
R738
R697
R691
R297
R292
C112
R140
R027
R262
(AEP, UK)
D107
C120
D110
R132
D106
C097
R694
R698
R128
JW133
D104
(EXCEPT AEP, UK)
R028
Q292
A A
E
A A
JW081
R261
JW002
WH013
JW073
D671
R263
A
C109
R107
Q106
C118
R122
JW115
C241
R105
E
C114
R150
(Page 33)
R699
R110
C110
C116
R120
A A
R295
K
E
R004
D016
JW696
R702
JW001
1
C041
1
R259
D244
Q291
D292
C105
Q108
K
D108
K K
R290
A
A A (AEP, UK) E R291
(AEP, UK)
C103
E
JW201
K K
R130
Q102
D068
K K
Q046
JW664
C684
D063 A
R260
Q104
R118
R703
(EXCEPT AEP, UK)
R264
D291
E
E
1
IC672
JW694
(AEP, UK)
R293
R116
R114
R183
R296
JW121
JW122
R126
R737
R026
C181
D101
R108
G
18
9
(AEP, UK)
JW123
R124
10
12
Q181
K K
WH201
JW695
JW699
E
JW124
A
D067
JW646
JR620
R144
JW130
JW132
C132
A
JW117
5
C730
JW119
JW125
JW202
C731
R739
JW128
C104
JR202
Q043
R001 JW018
R002
R043
R041
A A
JR001
JW649
C106
JW129
B
D045
R049
R733
D695
R284
DRIVER BOARD
CN701
R731
CN692
JW120
E
D692
C610
R605
R701
JR104
C182
R181 JW126
R182
C282
R700
R186
E
Q182
E
R692
R693
1
JW127
R185
R106
R281
R184
R282
Q183
K
JR615
R007
R017
JW017
R008
R048
R038
R734
E
R047
(EXCEPT AEP, UK)
R730
K
JR204
Q282
(Page 26)
R695
R696
D281
E
JW131
JW503
Q281
JR203
R032
C008
C043
R086
R732
C281
R037
Q022
R044
(AEP, UK)
JW691
JR619
A A
C045
E
R280
R283
E
R050
JW690
R735
HP1
(PB)
(DECK-A)
R029
JW701
JW658
JW655
JW656
JW645
JW722
JW721
JR612
C044
Q041
C609
JW629
(AEP, UK)
C046
C047
R606
R645
JW703
JW709
R046
R045
JW087
(AEP, UK)
R
(AEP, UK)
(EXCEPT AEP, UK)
R051
R188
JR623
JR603
R202
R608
C608
JW107
G
BOARD
BOARD
C1 PTWH093
C2 PTCN093
(Page 38) (Page 40)
R663
R024
R602
(AEP, UK)
JR608
JR604
JW647
JW653
D661
R025 R030 JW650
JW639
C613
C614
C601
R607
R604
BOARD
D PTWH091
(Page 38)
(EXCEPT AEP, UK, AUS)
R662
JR701
L
(AUS)
(AEP, UK)
JW702
R654
R653
C605
R656
JW708
JW713
JW118
JR801
R644
R643
R619
R625
R626
R616
C694
R618
R617
C693
C624
C626
R634
C621
R629
R630
R632
R628
JW640
C611
R655 R603
JW705
JW657
EXCEPT
AEP, UK
TP601
JW707
H
C699
JW601
JW638
JW641
C606
C607
JW660
HP BOARD
WH230
15
CN802
JW642
C604
JW704
R657
JW659
E
14
(EXCEPT AEP, UK)
D694
R612
D
HRPE1
(REC/PB/ERASE)
(DECK-B)
JW608
R661
C603
JR611
1
JR622
R610
S
D
JW602
JR609
JR610
D662
AM LOOP
11
JW607
C644
JR625
C664 C663
C662
SUPPLIED WITH THE
ASSEMBLED BLOCK
C913
JW808
FM 75Ω
(COAXIAL)
TUNER PACK
C912
JW011
3
R620
R311
C311
Q302
R302
JW807
JW654
CN301
S
D
G
CNA301
JW710
JW711
JW712
G
S
JW605
JW603
C612
Q304
C301 D C302
R301
JW600
JW630
S
D
Q301
G
JW806
JW606
C642
C641
R601
R652
JW301
JR601
G
C734
(AEP, UK)
JW631
Q303
R622
R623
JR602
14
R651
FB601
JW604
10
C643
R621
1
R304
C303
S
C304
R303
D
R624
IC601
C909
D697
15
8
JR605
Q305
G
R638
28
E
R318
R658
JW632
FB602
C321
JR606
C318
Q311
JW627
S
D
Q312
C733
JW634
D
JW623
Q306
G
E
JW635
C622
S
Q601
E
(Page
34)
JW620
Q309
CN302
1
R317
R316
JW633
G
R305
C306
R659
JW622
S
D
S
D
A
JW626
G
Q307
G
C305
K
D301
JR607
K
C317
Q310
JW621
R313
JW624
F
C312
Q308
C320
PANEL
BOARD
CN101
R312
E
R636
R635
R631
1
2
C911
FB693
C623
R627
R609
JW652
JW625
CN601
R637
BIAS OSC
1
9
R315
R314
D024
JW044
L311
C316
C319
C322
B
JW617
R633
C313
D801
18
C602
(Page 34)
CN691
CN801 11PIN CONNECTOR (EXCEPT AEP, UK)
CN802 15PIN CONNECTOR (AEP, UK)
R801
CN801
C695
19
1
2
C314
R615
C653
C654
C655
C651
C315
JW804
C801
JW619
C652
CN694
JW805
JW616
JW637
JW613
JR651
C950
PANEL
BOARD
CN701
JW618
JW609
JW801
JW610
C661
JW611
JW663
G
F
JW802
JW803
JW614
E
R810
R812
JW661
(Page 24)
C
(AEP, UK)
R809
BD
BOARD
CN710
C625
A
15
(15)
CX-JN10
6-14. PRINTED WIRING BOARD – HP Section – • See page 23 for Circuit Boards Location.
6-15. SCHEMATIC DIAGRAM – HP Section –
:Uses unleaded solder.
E
MAIN BOARD
WH201
(Page 32)
FB221
5
WH230
5P
WH230
JW222
J221
GND
JW224
JW222
R-IN
L-IN
R224
JW216
R225
R223
R226
∗
∗
∗ R225,226
150 (EXCEPT AEP,UK)
JW225
JW223
180 (AEP,UK)
JW221
FB221
R221
(CHASSIS)
15
C250
(15)
1-688-400-
J221
PHONES
• Semiconductor Location – MAIN Board –
Ref. No.
Location
Ref. No.
D009
D015
D016
D017
D018
D019
D020
D021
D022
D023
D031
D032
D033
D041
F-11
F-10
E-10
F-10
F-10
E-10
E-10
E-10
E-10
H-7
H-8
F-8
F-8
D-9
D042
D043
D044
D045
D063
D064
D065
D066
D067
D068
D069
D101
D103
D104
Location
D-9
D-9
D-9
D-8
F-7
F-7
F-6
F-6
D-8
D-9
F-7
F-4
H-5
G-3
Ref. No.
D105
D106
D107
D108
D109
D110
D111
D231
D232
D235
D236
D239
D240
D241
Location
H-4
H-3
G-4
G-3
G-5
G-4
H-6
G-8
G-7
G-7
G-7
G-6
G-7
H-6
Ref. No.
D243
D244
D281
D291
D292
D301
D661
D662
D663
D671
D691
D692
D693
D694
Location
G-5
F-5
E-3
F-4
G-4
B-2
C-5
C-5
C-4
F-6
D-7
D-7
D-7
C-6
JW221
R223
150
C250
0.47
R225
(EXCEPT AEP, UK)
JW203
R224
150
R221
2.2k
JW225
JW226
R222
2.2k
(AEP,UK)
R222
R226
(EXCEPT AEP,UK)
(Page 29)
(AEP,UK)
L OUT
(EXCEPT AEP,UK)
(AEP, UK)
(EXCEPT AEP, UK)
(AEP, UK)
R-OUT
JW226
HP BOARD
PHONES
Ref. No.
Location
D695
D697
D801
F-4
B-5
B-7
IC001
IC002
IC003
IC601
IC672
H-8
H-7
G-8
C-4
F-5
JW690
D-6
Q022
Q023
D-10
F-9
Ref. No.
Q024
Q041
Q043
Q045
Q046
Q047
Q063
Q064
Q101
Q102
Q103
Q104
Q105
Q106
Location
F-8
D-8
D-8
E-9
E-9
E-9
F-7
F-7
G-5
G-3
G-5
G-3
G-5
G-3
Ref. No.
Q107
Q108
Q109
Q110
Q111
Q112
Q117
Q118
Q119
Q120
Q121
Q122
Q123
Q124
33
Location
H-5
G-3
H-5
H-4
G-6
G-4
H-6
H-4
H-6
H-4
H-6
H-3
H-7
H-4
33
Ref. No.
Q129
Q130
Q181
Q182
Q183
Q231
Q232
Q233
Q234
Q235
Q281
Q282
Q291
Q292
Location
H-7
H-5
F-4
F-3
E-3
G-7
F-7
G-6
G-6
G-6
E-2
F-2
F-4
G-4
Ref. No.
Q301
Q302
Q303
Q304
Q305
Q306
Q307
Q308
Q309
Q310
Q311
Q312
Q601
Location
C-3
D-3
C-3
C-3
C-3
C-3
B-3
B-3
B-3
B-2
C-2
C-2
C-3
(CHASSIS)
CX-JN10
6-16. PRINTED WIRING BOARD – PANEL Section – • See page 23 for Circuit Boards Location.
11
12
13
14
15
A
16
R908
C908
R909
R910
C910
R911
C911
C912
R912
R914
R913
R915
R916
R917
R919
R921
R920
R934
R933
R935
R936
R939
R937
R938
R940
R941
R968
JW901
R932
R918
C909
R927
17
18
R905
A
A
D623
D622
K
K
K
2
46
R928
R926
R925
R924
(AEP, UK, EA)
C927
C935
JW991
R953
JW990
JW989
JW970
D607
D608
D609
D611
JW987
JW988
JW986
R957
R959
JW950
C919
JW992
C902
R902
C924
JW958
JW954
C504
C920
W2
JW993
JW959
C923
JW938
JW956
JW957
JW955
JW946
R504
JW945
C508
JW940
JW960
R960
X901
JW412
R503
JW961
C922
1
JW949
E
R962
R961
X902
JR905
R958
JW937
JR909
R975
C933
C921
100
R502
R963
R249
JW962
JW948
JW947
JW963
R971
D508
D501
JW933
IC901
C918
Q901
JW934
JW932
JR910
R254
JW985
E
D503
D509
JW997
JW944
JW410
(Page 32)
JW411
JW409
JW408
JW406
MAIN
BOARD
CN601
JW931
Q903
C507
R506
JW103
JW929
C926
81
JW943
IC502
50
30
Q607
JW935
C509
R114
F
C503
D505
D506
R507
JW201
1
R643
R642
K
W1
80
E
K
K
JR903
R976
R601
Q902
JR914
3
(AEP, UK) JR703
JW104
5
4
D504
JW109
G
E
C510
R248
IC501
JW942
R501
1
K
R644
JW983
R972
3
A
D626
JR912
51
C502
R247
K
A
D627
R645
31
R505
JW923
JW110
JW919
JW917
JW918
JW105
JW916
JW914
JW106
JW924
C501
JR101
D101
29
F
JR102
R102
(AEP, UK)
JW107
JW915
CN101
JW920
R121
D507
R118
JW984
JW913
R954
JW925
JW904
30
R950
JW908
R120
JW922
JW921
JW911
JW909
JW912
JW108
R817
JW905
E
D612
D614
JW978
R947
R949
R122
D625
K
K
JW972
JR911
(EXCEPT AEP, UK)
JW906
D624
K
JW971
R946
R948
(AEP, UK)
R106
(E51)
K
A
JW973
JW951
R101
JW980
R964
(AEP, UK)
JW979
R965
JW907
R702
R104
R966
R818
R110
R967
JW982
R709
JW995
R105
R103
JW903
R113
R107
R109
R108
R943
R701
D621
K
K
JW966
R929
JW967
(AEP, UK)
JW969
(E51)
D620
A
JW974
R923
JW968
R708
C809
R969
R970
R703
K
A
K
JR913
R922
JW975
R931
JW996
R705
R707
JW976
CN701
D
50
JW965
JW977
R706
C
H
JW603
Q604
E
SUPPLIED WITH THE
ASSEMBLED BLOCK
Ref. No.
Location
Ref. No.
Location
Ref. No.
Location
Ref. No.
Location
D101
D402
D501
D503
D504
D505
D506
D507
D508
D509
D601
F-5
J-8
F-9
G-10
G-9
G-8
G-8
F-8
F-10
G-9
J-17
D602
D607
D608
D609
D611
D612
D614
D620
D621
D622
D623
J-15
C-12
C-12
C-11
C-11
C-11
C-10
B-18
B-18
A-18
A-18
D624
D625
D626
D627
B-18
B-18
C-18
C-18
IC201
IC501
IC502
IC801
IC901
I-11
F-9
G-8
B-9
F-14
Q601
Q602
Q603
Q604
Q605
Q606
Q607
Q901
Q902
Q903
J-14
J-14
J-15
J-12
J-11
J-12
F-11
G-11
F-10
G-10
34
34
R625
R627
TAPE MECHANSM
DECK BLOCK
• Semiconductor Location
R631
R628
JR601
R610
E
JW601
R626
CN601
E
R630
JR602
Q603 D602
E
C601
JR219
JW604
Q601
R612
E
R608
R263
JW605
R637
JW953
JW952
R629
R611
JR220
Q605
KEY BOARD
CN303
R974
R228
R264
E
10
D402
(Page 36)
K
JW998
JW939
JW213
JW212
JW211
1
Q606
R262
Q602
R609
C413
IC201
R261
C216
JW210
C414
R419
C215
11
R607
R119
JR204
J
R112
R111
JR402
C214
R416
R415
20
C415
R418
R334
JR401
JW404
JW101
CN403
R417
C213
R335
JR218
JW403
JW936
R226
R225
JW207
1-688-380-
R227
JW413
R336
JW206
JR213
JR205
JW203
JW405
JW407
JW202
R973
1
JW402
JW401
2
I
JW930
13
JW102
H
6
49
R704
R944
R942
45
R930
C915
C914
R945
PANEL BOARD
JW994
3
C916
7
R904
1
R903
FL902
FLUORESCENT INDICATOR TUBE
C904
1
C903
C905
IC801
JW902
G
B
C917
MAIN BOARD
CN694
20
R906
C907
A
(Page 32)
19
R638
10
R639
9
JW607
8
JW608
7
R641
6
R640
5
JW606
4
C906
3
JW926
2
R907
1
:Uses unleaded solder.
D601
(13)
CX-JN10
• See page 42 for IC Block Diagrams.
6-17. SCHEMATIC DIAGRAM – PANEL Section –
• See page 42 for Waveforms.
• See page 45 for IC Pin Function Description.
G1
G4
G2
G3
G5
G6
G7
G8
G9
G10
S2
S1
G11
S3
S4
S5
S6
S9
S8
S7
S10
S11
S12
S13
S14
S15
S18
S16
S19
S17
S20
S21
S22
S23
S24
S26
S27
S25
S28
S29
G1
R902 47k
JW902
S30
C902 100p
G2
R903 47k
C904 100p
G3
R904 47k
C903 100p
G4
C905 100p
C907 100p
C906 100p
G5
R906 47k
C908 100p
R905 47k
C909 100p
G7
G6
G8
R908 47k
R909 47k
R907 47k
C912 100p
C911 100p
C910 100p
G9
R910 47k
R913 100k
G11
S1
G10
R942
1.8k
R911 47k
R943
1.8k
C915
0.1
R912 47k
R916 100k
R915 100k
R914 100k
S4
S5
S2
S6
S3
R919 100k
R918 100k
R917 100k
S7
R922 100k
R921 100k
R920 100k
S10
S8
S11
S9
R925 100k
R924 100k
R923 100k
S12
S15
S13
R928 100k
R927 100k
R926 100k
S16
R930 100k
R929 100k
S18
S17
S14
R933 100k
R932 100k
R931 100k
S19
S22
S20
S23
C914
47
35V
S21
R936 100k
R935 100k
R934 100k
S24
R939 100k
R938 100k
R937 100k
S27
S25
S29
S26
R968 100k
R941 100k
R940 100k
S30
S28
FL902
FLUORESCENT INDICATOR TUBE
JW901
R944
6.8k
S10
S10
S11
S12
S13
S12
S13
S14
S11
S16
S15
S16
S17
S17
S18
S21
S23
A11
A4
S20
S18
T12
S19
T11
S20
T10
S21
T9
S22
T8
S23
T7
S24
T6
S25
T5
S26
C2
S28
C4
R702 100
CD_RES
S27
(Page 31)
S29
R704
R969
100k
S30
JW987 100
DI
R970
100k
A3
D626
MC2836
CL
DO
C935
330
6.3V
C926
0.1
K7
C5
C927
0.1
R967 100k
R705
R638
1k
K2
R645 2.2k
D627
MC2836
R945
6.8k
R639
1k
K8
C6
R640
1k
K1
R706 100
R641
1k
R965 100k
C8
JW995 100
MP3_CE
R642
1k
JR903
0
S13
R966 100k
R708
FSYNC
R643
1k
S12
R964 100k
C9
WRQ
S11
C917
4.7
50V
D620
MC2836
R709 100
R644
2.2k
DRF
S10
D621
MC2836
C3
CD_CE
S9
D622
MC2836
C1
R703 100
S8
D623
MC2836
R701 100
S7
D624
MC2836
C7
D625
MC2836
R707 100
S6
CN701
11P
C916
4.7
50V
D-GND
Q607
DTA114EKA
-T146
BASS A
CN101
30P
R601
100
BASS B
A18
FIX0
B HALF/S10
REC FWD/S11
A HALF/S12
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
A MODE/S13
R949 100k
TRE B
VDD4
K4
TRE A
CD NUMBER SENS
R948 100k
TUNED
K3
VOL A
R947 100k
STEREO
R946 100k
K6
VOL B
K5
JOG B
D607
1SS133
JOG A
B+ SWITCH
(E51)
D608
1SS133
C17
S18
D609
1SS133
(EXCEPT AEP,UK)
C16
(AEP,UK)
D611
1SS133
S20
S23
(AEP,UK EA)
D612
1SS133
S21
D614
1SS133
(E51)
(AEP,UK)
CD_ON
S9
S9
S8
S8
S7
S7
S6
S6
R950 100k
B MODE/S9
VDD3
TUNER MUTE
A-GND
REC REV/S8
L2
A8
R111 1k
L1
E1
R112 1k
A17
S4
B PHOTO/S7
S4
LED R
O-BIAS
R119 1k
A20
CLK
S3
VSS2
S2
C918 0.1
D508
1SS133
S-OUT
S3
A PHOTO/S6
PB2
S2
S1
S1
VDD2
VF-ON
R122 1k
A20
VF ON
BU-UP/DOWN SW
KEYSCAN
A16
O-POWER
POWER LED
A14
C1
A10
(AEP,UK)
LC876756C-52N7-E
(EXCEPT AEP,UK)
G10
G9
G9
G8
G8
CD DRF
G7
TU DI
G6
CD WRQ
G5
CD DI
G4
G7
G6
A6
STB-I/O
R971
100k
D-GND
G5
C3
A11
C5
POWER DOWN
G2
RMC
G2
G1
RDS CLK
HOLD
KEY1
KEY3
KEY2
G3
SPEANA-H
SPEANA-M
SPEANA-L
CD BUSY
VDD1
G3
TU-SIG/MIC
CF2
CF1
MUTE
R954
3.9k
RDS-DATA
VSS1
RDS-CLK
XT2
SYS-
XT1
V-STBY(EVER)
MP3 SYNC
CD CLK
A18
TU CE
C213
0.1
LCK
R225
100
RDS DO
D101
1SS133
HOLD
CLK-SHIFT
CD DO
C6
CD CE
C4
+4V
MP3 CE
G4
CD-NUMBER SENS
CD RESET
R113 1k
LC876772B-52N2-E
POWER
R953 100k
CD-VM
R121 1k
G10
A16
O-MUTE
TU/EVOL DO
R120
G11
IC901
A12
RESET
R114 1k
G11
SYSTEM CONTROLLER
SPEANA
G1
A1
A-GND
MIC-OUT
I-MIC
R973
TU-MUTE
C215 100p
R959
470k
R963 1k
R254 220k
K7
K8
K8
K1
K1
K2
K2
K5
K5
C922
22p
D509
1SS133
L5
L4
L3
R264 2.2k
(AEP,UK)
K6
R334 10k
R263 10k
R336 10k
∗
K6
X902
8.64MHz
X901
32.768KHz
R972
R974 100k
R228 10k
R262 10k
L2
L1
A10
A8
R227 10k
R226 10k
A2
A7
A17
A1
R976
2.2k
R335 10k
R261 10k
C216 100p
R103
39k
R958
10M
D-GND
K7
C933
3900p
B8
100k (EXCEPT AEP,UK)
C214 100p
R118
10
B9
-VFL
B10
68k (AEP,UK)
R960 100
R957 100k
∗ R972,973
VF2
R975 100k
TU-SIG
R962 1k
R961 1k
VF1
R102 JR703
39k
0
VDD
∗
R104 1k
R101
22k
CN403
23P
E3
A12
A15
C9
A5
A10
C8
C7
C2
A7
A14
A2
LED L3
V-BASS
E2
SOL B
SOL A
LED L1
LED L2
O-MOTOR
O-BIAS
LCK
DATA
IC201
BU2099FV
R117
A18
R116
A3
R108 1k
NC
A4
R109 1k
VSS
R110 1k
TUNER TUNE
PB2
LED DRIVE
PLL-CE
STEREO
LED R2
DRIVE,
LED R3
MOTOR/PLUNGER
SO
A5
LED R1
A7
DATA
CLK
A6
R106 1k
VDD
R105 1k
R107 1k
IFC
OE
A8
CLK
A15
K3
K3
K4
K4
O-POWER LED
E2
R249
27k
C919
18p
C920
22p
C923
22p
(Page 37)
LATCH(ECHO)
C924
0
E3
DATA(ECHO)
E1
CLK(ECHO)
A18
R248 100k
V-BASS
R501
180
R247 12k
D501
1SS133
R504
10k
VM
REMOTE CONTROL
R507
10k
B10
RECEIVER
B10
+4V REGULATOR
R818
56k
VO
NOISE
CONT
VIN
C601
47
16V
GND
B9
C921
0.1
R502
47k
Q601
2SB1068
D507
MTZJ T-72
11B
C501
1
50V
PLUNGER DRIVE
(DECK-A)
R609
1k
D505
1SS133
D504
1SS133
R506
330
(DECK-B)
VDD(STBY)
VDD
R817
47
CN601
13P
R625 47k
T12
RMC
R416
270k
R
Q902
DTA124EKA
Q903
DTC144EKA
G
IC502
M62703ML
Q902,903
STANDBY SWITCH
RESET SIGNAL
R611
1k
A-MODE
R627
47k
A-SOL
R419
1k
C415
0.1
C413 R415
1
100
50V
A-PHOTO
D402
1SS133
C414
0.1
R418
470k
R417
15k
GND
T11
A-HALF
R628
47k
CAPM+
Q603
2SB1116
35
35
TAPE MECHANISM
DECK BLOCK
T10
R630
47k
REC(FWD)
T6
B-PHOTO
T9
B-MODE
R637
47k
SUPPLIED WITH
THE ASSEMBLED
BLOCK
B-HALF
T8
B-SOL
T7
REC(REW)
D-GND
Q606
RN1202TPE
R612
1k
C510
0.1
T5
GENERATOR
Q603,606
C508
0.1
R626
47k
PLUNGER DRIVE
L5
SWITCH
C503
1
50V
C502
0.01
V
C509
22
50V
Q602
2SB1116
D503
1SS133
D506 1SS133
Q605
RN1202TPE
R610
1k
R503
47k
R505 4.7k
Q602,605
L4
C507
0.022
B8
R631 47k R629 47k
R608
1k
R607
1k
C504
1000
6.3V
B8
GND
(EXCEPT AEP,UK)
MOTOR DRIVE
D602 1SS133
CAPSTAN/REEL
Q604
RN1202TPE
IC501
MM1614A
B9
IC801
GP1UM271XK
C809
47
16V
Q901
2SC3052
RESET
Q601,604
L3
D601 1SS133
(Page 30)
S5
S5
LED L
MIC-OUT
CX-JN10
6-18. PRINTED WIRING BOARDS – KEY Section – • See page 23 for Circuit Boards Location.
:Uses unleaded solder.
KEY BOARD
LED901
STANDBY/ON
R803
R804
S315
POWER
3
C801
2
C802
R801
R802
1
S801
S307
VOLUME
MODE
S301 − 315,
S317− 323
R312
S308
ENTER
S803
TREBLE
JW325
JW323
C808
C402
R401
C409
S301
STOP/CLEAR
PLAY/PRESET
R413
JW404
JW403
IC401
C408
JW402
R409
JW302
R302
JW310
JW311
JW309
JW308
JW306
JW307
JW305
R807
JW304
1
S305
TUNING UP
S304
R305
R304
PAUSE/SET
D401
C405
S303
TUNING DOWN
R403
R808
SDG
LED201, S306
i-BASS
S317
S306
H
S318
PTY
(Page 34)
JW317
R318
SYNC DUB
S313
S317
RT
REC
REC MUTING
CN302
DISC DIRECT PLAY
S320
S321
3
R326
S322
2
R327
C419
C403
J401
MIC
CD KEY BOARD
S319
VR401
MIC MIXING
1-861-660-
FB401
C441
JW401
S313
R324 R323
PANEL BOARD
CN403
OPEN/CLOSE
JR404
R402
R405
C416
JR403
R411
R404
S314
R317
R306
JW315
(AEP, UK)
S318
R231
CN303
C406
11
LED201
JW316
R322
JW318
R321
JW301
JW312
Q401
C804
2
R805
R806
C803
3
JW303
R303
R406
C404 C407
R407
R410
R412
R432
C411
JW405
R301
S302
C412
C410
R311
S802
BASS
1 C807
JW406
JW322
R408
2
R815
R813
JW408
R414
3
R816
R316
JW314
R809
R814
JW407
S312
VIDEO/AUX
CD
JW321
S309
S310
TAPE A/B
JW320
R812
C805
R810
JW313
TUNER
BAND
JW319
C806
R314
1
R315
S311
R313
2
JW326
S804
MULTI JOG
JW324
R811 3
CN301
R325
JW327
S323
1
DISC CHANGE
R328
R329
1-861-66111
(11)
36
36
(EXCEPT AEP, UK)
(11)
CX-JN10
R801
10k
R803
10
K5
K6
K8
K7
6-19. SCHEMATIC DIAGRAM – KEY Section –
R809
10k
A
1
R811
10
A
S801
2
B
B
3
B8
S301
S302
R305
1.2k
S303
R306
1.2k
S304
R810 C805
10k 1000p
R805
10k
R807
10
R813
10k
A
1
STOP/
PAUSE/
TUNING DOWN
CLEAR
PRESET
R812
10
S306
S305
i-BASS
PLAY/
C806
1000p
K1
R304
1k
3
R804
10
K2
R303
820
K4
R302
1k
C802
1000p
K3
R301
0
C801
1000p
A
2
B
B10
R311
0
R312
1k
R313
820
R314
1k
R315
1.2k
R316
1.2k
S307
S308
S309
S310
MODE
ENTER
CD
TAPE A/B
R321
0
R322
1k
R323
820
R324
1k
R317
1.8k
S311
S312
TUNER
VIDEO/
BAND
AUX
R318
1.8k
R806
10k
C803
1000p
C804
1000p
B
R814 C807
10k 1000p
S318
RT
PTY
R816
10
SYNC DUB
CN301
5P
CN302
5P
R326
1.2k
R327
1.8k
R329
2.7k
D-GND
S319
(AEP,UK)
R328
1.8k
KEY3
D-GND
S317
C808
1000p
S314
REC
REC MUTING
KEY3
S315
3
R808
10
S313
R325
1.2k
POWER
MULTI JOG
C
2
SET
S804
1
BASS
C
TUNING UP
R815
10
S802
3
B9
TREBLE
C
2
R802
10k
S803
1
VOLUME
C
NC
NC
NC
NC
NC
NC
S320
OPEN/CLOSE
S321
3
2
S322
S323
DISC
1
CHANGE
DISC DIRECT PLAY
CN303
23P
A-GND
(EXCEPT AEP,UK)
MIC-OUT
I-MIC
C412
1 50V
VDD
R414
10
D-GND
K7
R408
100
K7
K8
C408
0.1
50V
C411
820p
K8
K1
8
3
R404
100
1
2
K1
K2
R413
33k
K2
K5
IC401(1/2)
NJM4565M-TE2
K5
C404
0.22
50V
R402
4.7k
R405
2.2k
J401
MIC
K6
K6
K3
IC401(2/2)
NJM4565M-TE2
K4
K4
5
O-POWER LED
7
6
LED901
SLI325-URC
LED201
SLR325-VC
CLK(ECHO)
i-BASS
R406
270k
VR401
10K
MIC MIXING
LATCH(ECHO)
DATA(ECHO)
C407
82p
4
MIC AMP
STANDBY/ON
C441
0.1
V-BASS
R432
10k
VM
B10
B10
B9
R412
2.2k
R231
1k
R410
2.2k
B9
B8
C419
0.1
B8
S
(CHASSIS)
C405
1
50V
R403
220k
Q401
2SK2158
MIC LEVEL
AGC
37
37
0.45UH
R407
2.7k
D401
1SS133
C406
220
10V
FB401
R409
2.2k
R411
2.2k
R401 100k
C410
22
50V
C409
10
50V
C402 0.1
VDD(STBY)
C403 0.0047
(Page 35)
C416
0.1
50V
JW401
K3
CX-JN10
6-20. PRINTED WIRING BOARD – PT Section – (AEP, UK, AUS)
• See page 23 for Circuit Boards Location.
:Uses unleaded solder.
PT BOARD
JW204
2
CN091
1
D
PR093
PT002
POWER TRANSFORMER
(MAIN)
WH091
1
WH093
MAIN
BOARD
WH011
(Page 32)
1
RY001
∗
PT011
POWER TRANSFORMER
(SUB)
JW218
C1
7
∗NOT REPLACEABLE:
MAIN
BOARD
WH013
(AEP, UK)
(Page 32)
BUILT IN TRANSFORMER
11
(AUS)
K
JW084
(AC IN)
JW214
(AEP, UK)
A
15
D091
D092
A
38
38
A
K
K
C091
1-689-399-
(15)
CX-JN10
6-21. SCHEMATIC DIAGRAM – PT Section – (AEP, UK, AUS)
(AEP,UK)
WH091
7P
VL(AC)
VL(AC)
GND(M)
FIL-1
FIL-2
(Page 28)
P-ON
VSTBY
PT002
POWER TRANSFORMER
WH093
11P
(MAIN)
VM(AC)
VM(AC)
∗ NOT REPLACEABLE:
VH(AC)
BUILT IN TRANSFORMER
VH(AC)
VL(AC)
∗
VL(AC)
GND(M)
FIL-1
(Page 28)
FIL-2
(AEP,UK)
P-ON
C091
0.1
VSTBY
(AUS)
RY001
PT011
POWER TRANSFORMER
D091
MC2836
(SUB)
JW218
PR093
CN091
2P
(AC IN)
D092
MC2838
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
39
39
CX-JN10
6-22. PRINTED WIRING BOARD – PT Section – (E, EA, E51, SP, TW)
• See page 23 for Circuit Boards Location.
:Uses unleaded solder.
PT BOARD
(AC IN)
JW007
PT002
POWER TRANSFORMER
(SUB)
2 CN090
1
JW017
K
K
A
A
D002
D003
PR003
A
K
PT004
POWER TRANSFORMER
(MAIN)
(E, EA, E51, SP)
(TW)
S001
1
JW001
JW031
JW002
S001
-1
JW022
CN093
C2
VOLTAGE
SELECTOR
MAIN
BOARD
WH013
(Page 32)
100 − 120V
RY001
JW032
-2
11
JW020
(TW)
JW021
220 − 240V
∗
∗NOT REPLACEABLE:
BUILT IN TRANSFORMER
12
C003
1-688-763-
40
40
(12)
CX-JN10
6-23. SCHEMATIC DIAGRAM – PT Section – (E, EA, E51, SP, TW)
PT004
POWER TRANSFORMER
CN093
11P
(MAIN)
VM(AC)
VM(AC)
VH(AC)
VH(AC)
(E,EA,E51,SP)
VL(AC)
-1
VL(AC)
JW032
S001
GND(M)
VOLTAGE
(TW)
SELECTOR
FIL-1
100-120V
∗
(Page 28)
FIL-2
-2
220-240V
P-ON
VSTBY
C003
0.01
∗ NOT REPLACEABLE:
BUILT IN TRANSFORMER
CN090
2P
PR003
(AC IN)
RY001
PT002
JW031
POWER TRANSFORMER
D002
MC2836
(SUB)
(TW)
D003
MC2838
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
41
41
CX-JN10
• Waveforms
– BD Board –
– MAIN Board –
– PANEL Board –
• IC Block Diagrams
– BD Board –
1 IC721 4 (RF) (CD Play Mode)
qa L311 6, 7 (REC Mode)
qf IC901 qd (XT2)
IC721
TIN1
qg IC901 qh (CF2)
TIN2
50 Vp-p
VSS
VDD5
DRF
RES
WRQ
DO
DI
CL
CE
RF
TEC
TE
DRF
WRQ
DO
DI
CL
CE
FR
VVDD
PCKIST
VVSS
PDO2
PDO1
CONT1
CONT2
CONT3
PH
AGC
EQ
BH
LPF
+
–
TBAL
+
–
TBAL
LPF
SW
+
–
LPF
+
–
+
–
RFMON
LEVEL SET
REFI
Approx.
180 mVp-p
MIX
+
–
30.6 µs
qs L311 5 (REC Mode)
LDD
LDS
+
–
FIN2
2 IC721 qd (FE) (CD Play Mode)
65 64 63 62 61
FE
FIN1
19 µs
78 77 76 75 74 73 72 71 70 69 68 67 66
LDD
LDS
3.3 Vp-p
80 79
FR
VVDD
PCKIST
VVSS
PDO2
PDO1
CONT1
CONT2
CONT3
28 Vp-p
1.3 Vp-p
LC78646E-E
MONI
CONT
–
+
1 Vp-p
VREF
RAM
DEFECT
TRACK JUMP
SERVO PROCESSOR
A/D
19 µs
TDO
qd Q310 (Collector) (REC Mode)
Approx.
150 mVp-p
AUTO ADJUST
JITTC
SLCO
SLCIST
EFMIN
RF
RFVDD
RFVSS
FIN1
FIN2
TIN1
TIN2
VREF
REFI
FE
TEC
TE
RFMON
JITTC
ADAVDD
ADAVSS
TDO
15 Vp-p
19 µs
4 IC721 rk (XOUT)
4 Vp-p
SLCO
1
SLCIST
2
EFMIN
3
RF
4
5
6
FIN1
7
FIN2
8
TIN1
9
TIN2
10
VREF
11
REFI
12
FE
13
TEC
14
TE
15
RFMON
16
JITTC
17
ADAVDD
18
ADAVSS
19
TDO
20
JITTER
DETECT
SW
SLICE LEVEL
CONTROL
S/H
D/A
FDO
SPDO
SLDO
GPDAC
DRF
DRF
RUPTURE DEFECT
PDO1
PDO2
FR
PLL
PCKIST
VCEC
VVDD
VVSS
FRAME SYNC
DETECT,PROTECT,INSERT,
EFM DECODE
CLV,CAV
CONTROL
SBCK/FG
FSEQ
V/P
SUBCODE DECODE CRC
16MOUT
XVSS
XIN
XOUT
XVDD
CLOCK
GENERATOR
WRQ
CL
CE
DI
DO
MONITOR SIGNAL SELECTOR
EFLG
C2F
FSX/16MIN
ERROR
CORRECTION
AUDIO CD
CONT1-3
SBCK/CONT6
CONT4,5
MONI1-5
RAM
COMMAND
INTERFACE
GENERAL PURPOSE
PORTS
INTERPOLATION
MUTE
8FS
DIGITAL FILTER
58 ns
ATTENUATION
DEEMPHASIS
EXTERNAL
AUDIO IN
ASDFIN
ASDACK
ASLRCK
SERIAL
OUT
DATA
DATACK
LRSY
AUDIO OUT
LPF
FDO
SPDO
SLDO
GPDAC
CONT4
CONT5
SBCK/CONT6
SBCK/FG
DEFECT
V/P
FSEQ
MONI1
MONI2
MONI3
MONI4
MONI5
1BIT DAC
LVDD
LVSS
LCHO
RCHO
RVDD
RVSS
FDO
SPDO
SLDO
GPDAC
CONT4
CONT5
SBCK/CONT6
SBCK/FG
DEFECT
V/P
FSEQ
MONI1
MONI2
MONI3
MONI4
MONI5
VSS
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
42
42
VDD(3.3V)
DOUT
TEST
3 IC721 qg (TE) (CD Play Mode)
ADAVDD
ADAVSS
116 ns
LDD
LDS
APC
DATA
DATACK
LRSY
ASDFIN
ASDACK
ASLRCK
16MOUT
EFLG
C2F
XVSS
FSX/16MIN
XIN
XOUT
XVDD
RVDD
RCHO
RVSS
LVSS
LCHO
LVDD
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
DATA
DATACK
LRSY
ASDFIN
ASDACK
ASLRCK
16MOUT
EFLG
C2F
XVSS
FSX/16MIN
XIN
XOUT
XVDD
RVDD
RCHO
RVSS
LVSS
LCHO
LVDD
CX-JN10
– DRIVER Board –
IC701, 712
BA6956AN
TSD
7
8
9
GND
RIN
6
FIN
5
VCC
4
VM
OUT2
3
OUT1
2
RNF
1
VREF
CONTROL LOGIC
– MAIN Board –
REC1N
REC2N
REC2O
INC2
INC1
INB2
INB1
INA2
INA1
OUT1
BAS1
OUT2
BAS2
BD3881FV
REC1O
IC601
28
27
26
25
24
23
22
21
20
19
18
17
16
15
BASS
VOLUME
TREBLE
LOGIC
CONTROL
5
6
7
8
9
10
11
12
13
14
PB1O
VOLIN1
VOLIN2
GND
TRE1
TRE2
VDD
CONT
VEE
TREBLE
PB2O
4
PB2N
PB1P
Q11
Q10
Q9
Q8
Q7
Q6
Q5
OE
BU2092F-E2
VDD
IC672
3
PB2P
2
PB1N
VOLUME
1
BASS
18 17 16 15 14 13 12 11 10
12 BIT
SHIFT
REGISTER
CONTROL
CIRCUIT
1 2
3
4
5 6 7 8 9
CLOCK
LCK
Q0
Q1
Q2
Q3
Q4
OUTPUT
BUFFER
(OPEN DRAIN)
VSS
DATA
12 BIT
STORAGE
REGISTER
43
CX-JN10
– PANEL Board –
Q11
Q10
Q9
Q8
Q7
Q6
Q5
Q11
OE
BU2099FV
VDD
IC201
20 19 18 17 16 15 14 13 12 11
12 BIT
SHIFT
REGISTER
CONTROL
CIRCUIT
5
6 7 8 9 10
Q0
Q1
Q2
Q3
Q4
VOUT
MM1614A
VIN
IC501
4
LCK
VSS
N.C.
DATA
1 2 3
OUTPUT
BUFFER
(OPEN DRAIN)
CLOCK
12 BIT
STORAGE
REGISTER
5
4
CURRENT
LIMITTER
BIAS
REFERENCE
−
+
44
1
2
3
CONT
GND
NOISE
THERMAL
SHUTDOWN
DRIVER
CX-JN10
• IC Pin Function Description
PANEL BOARD IC901 LC87696B-52D8 (SYSTEM CONTROLLER)
LC876772B-52N2-E (AEP and UK models), LC876756C-52N7-E (EXCEPT AEP and UK models)
Pin No.
Pin Name
I/O
1
SYS-MUTE
O
Line muting on/off control signal output terminal
Description
2
RDS DO
I
RDS serial data input from the tuner pack (AEP and UK models)
3
TU/EVOL DO
O
Serial data output to the tuner pack, motor/plunger/LED driver and electrical volume
4
CD RESET
O
Reset signal output to the CD DSP
5
CD CE
O
Chip enable signal output to the CD DSP
6
MP3 CE
O
Chip enable signal output terminal
7
CLK-SHIFT
O
Shift clock signal output terminal
8
LCK
O
Latch clock signal output to the motor/plunger/LED driver
9
TU CE
O
Chip enable signal output to the tuner pack
10
MP3 SYNC
I
SYNC signal input terminal
11
RESET
I
System reset signal input from the reset signal generator “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
12
XT1
I
System clock input terminal (32.768 kHz)
13
XT2
O
System clock output terminal (32.768 kHz)
14
VSS1
—
Ground terminal
15
CF1
I
System clock input terminal (8.64 MHz)
16
CF2
O
System clock output terminal (8.64 MHz)
17
VDD1
—
Power supply terminal (+3.3V)
18
POWER DOWN
I
Power down detection signal input terminal
19
TU-SIG/MIC
I
RDS signal input terminal (AEP and UK models)
MIC signal input terminal (except AEP and UK models)
20
CD BUSY
I
Optical pick-up up/down detection and tray open/close detection signal input terminal
21
SPEANA-L
I
Spectrum analyzer drive signal input terminal (low band)
22
SPEANA-M
I
Spectrum analyzer drive signal input terminal (middle band)
23
SPEANA-H
I
Spectrum analyzer drive signal input terminal (high band)
24
KEY3
I
Front panel key input terminal (A/D input)
25
KEY2
I
Front panel key input terminal (A/D input)
26
KEY1
I
Front panel key input terminal (A/D input)
Not used
Not used
Not used
Not used
Not used
Not used
27
HOLD
I
System malfunction signal (hold signal) input from the power amplifier circuit
28
RDS CLK
I
RDS serial data transfer clock signal input from the tuner pack (AEP and UK models)
29
RMC
I
Remote control signal input terminal
30 to 40
G1 to G11
O
Grid drive signal output to the fluorescent indicator tube
41 to 45
S1 to S5
O
Segment drive signal output to the fluorescent indicator tube
46
VDD3
—
Power supply terminal (+3.3V)
47
A PHOTO/S6
I/O
Deck-A tape reel rotating detection signal input and segment drive signal output to the fluorescent
indicator tube
48
B PHOTO/S7
I/O
Deck-B tape reel rotating detection signal input and segment drive signal output to the fluorescent
indicator tube
49
REC REV/S8
I/O
Recording (reverse direction) detection signal input and segment drive signal output to the
fluorescent indicator tube
50
B MODE/S9
I/O
Deck-B mode detection signal input and segment drive signal output to the fluorescent indicator
tube
51
FIX0
I/O
Not used
52
B HALF/S10
I/O
Deck-B cassette detection signal input and segment drive signal output to the fluorescent
indicator tube
45
CX-JN10
Pin No.
Pin Name
I/O
53
REC FWD/S11
I/O
Recording (forward direction) detection signal input and segment drive signal output to the
fluorescent indicator tube
54
A HALF/S12
I/O
Deck-A cassette detection signal input and segment drive signal output to the fluorescent
indicator tube
55
A MODE/S13
I/O
Deck-A mode detection signal input and segment drive signal output to the fluorescent indicator
tube
56 to 71
S14 to S29
O
Segment drive signal output to the fluorescent indicator tube
72
VDD4
—
Power supply terminal (+3.3V)
73
S30
O
Segment drive signal output to the fluorescent indicator tube
74
CD NUMBER
SENS
I
CD table address detection signal input terminal
75
TUNED
I
Tuning detection signal input from the tuner pack
76
STEREO
I
FM stereo detection signal input from the tuner pack
77
VOL A
I
Jog dial pulse input terminal (VOLUME)
78
VOL B
I
Jog dial pulse input terminal (VOLUME)
79
JOG A
I
Jog dial pulse input terminal (MULTI JOG)
80
JOG B
I
Jog dial pulse input terminal (MULTI JOG)
81
TRE A
I
Jog dial pulse input terminal (TREBLE)
46
Description
82
TRE B
I
Jog dial pulse input terminal (TREBLE)
83
BASS A
I
Jog dial pulse input terminal (BASS)
84
BASS B
I
Jog dial pulse input terminal (BASS)
85
TUNER MUTE
O
Tuner muting on/off control signal output terminal
86
LED L
O
LED drive signal output terminal
Not used
87
LED R
O
LED drive signal output terminal
Not used
88
CLK
O
Serial data transfer clock signal output to the tuner pack, motor/plunger/LED driver and BBE
controller
89
VSS2
—
Ground terminal
90
VDD2
—
Power supply terminal (+3.3V)
91
VF ON
O
Not used
92
KEYSCAN
O
Scan signal output for switches in the tape deck section
93
POWER LED
O
LED drive signal output terminal
94
POWER
O
Power on/off control signal output terminal
95
CD DRF
I
Focus on detection signal input from the CD DSP
96
TU DI
I
Serial data input from the tuner pack
97
CD WRQ
I
Interrupt request signal input from the CD DSP
98
CD DI
I
Serial data input from the CD DSP
99
CD DO
O
Serial data output to the CD DSP
100
CD CLK
O
Serial data transfer clock signal output to the CD DSP
CX-JN10
SECTION 7
EXPLODED VIEWS
NOTE:
• Items marked “*” are not stocked since they
• -XX and -X mean standardized parts, so they
are seldom required for routine service. Some
may have some difference from the original
delay should be anticipated when ordering
one.
these items.
• Color Indication of Appearance Parts
• The mechanical parts with no reference numExample:
ber in the exploded views are not supplied.
KNOB, BALANCE (WHITE) . . . (RED)
• Accessories are given in the last of the elec↑
↑
trical parts list.
Parts Color Cabinet's Color
• Abbreviation
TW : Taiwan model
EA : Saudi Arabia model
AUS : Australian model
SP : Singapore model
E51 : Chilean and Peruvian models
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
7-1. CASE SECTION
#1
4
3
7
chassis section
CDM74S-K6BD72
#1
(AEP, UK)
C952
C951
#1
6
#1
2
#1
1
#1
#1
not supplied
7
tape deck section
5
#1
6
Ref. No.
Part No.
Description
1
2
3
4
5
4-245-158-01
4-245-186-51
4-245-183-91
4-244-849-91
4-245-184-91
EMBLEM
PANEL, TRAY
CASE (SIDE-L)
CASE (TOP)
CASE (SIDE-R)
6
3-363-099-02 SCREW (CASE 3 TP2)
Remark
Ref. No.
Part No.
Description
Remark
7
C951
3-363-099-32 SCREW (CASE 3 TP2)
1-127-888-11 CERAMIC
0.1uF
10%
C952
1-127-888-11 CERAMIC
10%
#1
7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S
0.1uF
50V
(AEP, UK)
50V
(AEP, UK)
47
CX-JN10
7-2. TAPE DECK SECTION
#1
not supplied
51
#1
(EXCEPT
AEP, UK)
56
52
not supplied
53
55
54
panel board section
Ref. No.
51
52
53
54
48
Part No.
Description
4-245-177-11
4-245-179-11
4-245-182-11
4-245-176-11
ROTARY (JOG), KNOB
ROTARY (TRE), KNOB
PLATING, KNOB ROTARY (VOL)
PLATING, KNOB ROTARY (BASS)
Remark
Ref. No.
55
56
#1
Part No.
Description
Remark
1-796-485-51 DECK, MECHANICAL (CWM43FF13)
4-245-289-11 KNOB (MIC), ROTARY (EXCEPT AEP, UK)
7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S
CX-JN10
7-3. PANEL BOARD SECTION
#1
#1
105
101
not supplied
103
102
106
107
108
#1
(EXCEPT AEP, UK)
#1
104
#1
109
(EXCEPT AEP, UK)
not supplied
110
111
key section
Ref. No.
101
102
103
Part No.
Description
Remark
103
104
1-861-661-11 CD KEY BOARD
1-688-400-15 HP BOARD
3-229-336-01 SCREW, +BVWH TAPPING
(AEP, UK, E, E51, AUS)
3-229-336-11 SCREW, +BVWH TAPPING (EA, SP, TW)
4-245-189-01 REFLECTOR, REMOTE CONTROL
105
105
105
105
A-1055-453-A
A-4752-866-A
A-4752-867-A
A-4752-872-A
PANEL BOARD, COMPLETE (EA)
PANEL BOARD, COMPLETE (AEP, UK)
PANEL BOARD, COMPLETE (E, SP, TW, AUS)
PANEL BOARD, COMPLETE (E51)
Ref. No.
Part No.
Description
106
107
108
109
109
1-751-688-11
1-769-944-11
1-769-857-11
A-4732-748-A
A-4732-922-A
WIRE (FLAT TYPE) (13 CORE)
WIRE (FLAT TYPE) (11 CORE)
WIRE (FLAT TYPE) (5 CORE)
KEY BOARD, COMPLETE (E51)
KEY BOARD, COMPLETE (AEP, UK)
Remark
109
110
111
#1
A-4734-690-A
1-773-182-11
4-245-264-01
7-685-647-79
KEY BOARD, COMPLETE (E, EA, SP, TW, AUS)
WIRE (FLAT TYPE) (23 CORE)
GUIDE (I BASS)
SCREW +BVTP 3X10 TYPE2 N-S
49
CX-JN10
7-4. KEY SECTION
156
154
155
152
157
front cabinet section
151
153
Ref. No.
Part No.
Description
151
152
152
152
153
4-245-193-01
4-254-978-01
4-254-978-11
4-254-978-51
4-233-980-01
RING (BASS)
WINDOW, DISPLAY (AEP, UK)
WINDOW, DISPLAY (E, EA, SP, TW, AUS)
WINDOW, DISPLAY (E51)
RUBBER FOOT
154
4-245-171-11 KEY (CD) (DISC CHANGE. 1. 2. 3. Z)
50
Remark
Ref. No.
155
156
157
157
Part No.
Description
Remark
4-245-172-21 KEY (FUN) (TAPE A/B. TUNER BAND.
VIDEO/AUX. CD. N. x)
X-4956-404-1 KEY ASSY (POWER)
X-4956-405-1 KEY ASSY (OPE) (m. X. M. SYNC DUB.
z REC/REC MUTING. DISPLAY. ALBUM.
i-BASS) (EXCEPT AEP, UK)
X-4956-403-1 KEY ASSY (RDS) (m. X. M. SYNC DUB.
z REC/REC MUTE. i-BASS) (AEP, UK)
CX-JN10
7-5. FRONT CABINET SECTION
207
211
208
210
205
212
209
206
210
204
203
201
Ref. No.
202
Part No.
Description
201
202
203
204
205
4-245-198-01
4-245-160-21
4-245-196-01
4-245-197-01
4-245-159-11
WINDOW (2), CASSETTE
BOX (2), CASSETTE
SPRING (BOX CASS R), TORSION
WINDOW (1), CASSETTE
BOX (1), CASSETTE
206
207
4-245-195-01 SPRING (BOX CASS L), TORSION
4-254-979-01 CABINET, FRONT (AEP, UK)
Remark
Ref. No.
Part No.
Description
207
208
209
210
211
4-254-979-11
4-231-836-01
4-231-841-01
4-224-104-41
4-231-824-01
CABINET, FRONT (EXCEPT AEP, UK)
SPRING (HEART CAM-A)
SPRING (HEART CAM-B)
DAMPER
CAM (A), HEART
212
4-231-825-01 CAM (B), HEART
Remark
51
CX-JN10
7-6. CHASSIS SECTION
(E, EA, E51, SP, TW)
258
252
252
not supplied
not supplied
#2
#1
251
A
PT004
259
#1
254
#1
(AEP, UK, AUS)
252
#1
#1
252
not supplied
not
supplied
#2
251
#1 not supplied
not supplied
258
258
not supplied
not supplied
256
PT002
A
255
257
253
258
260
not supplied
B
258
A
(AEP, UK)
C911
C912
C913
not supplied
C950
258
B
#1
not supplied
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
not supplied
Ref. No.
Part No.
Description
251
251
252
253
253
1-688-399-15
1-688-763-12
4-900-386-01
3-703-244-00
3-703-571-00
PT BOARD (AEP, UK, AUS)
PT BOARD (E, EA, E51, SP, TW)
SCREW
BUSHING (2104), CORD (EXCEPT E)
BUSHING (S) (4516), CORD (E)
254
254
255
255
255
1-693-615-11
1-693-616-11
A-4752-863-A
A-4752-871-A
A-4752-874-A
TUNER (FM/AM) (EXCEPT AEP, UK)
TUNER (FM/AM) (AEP, UK)
MAIN BOARD, COMPLETE (AEP, UK)
MAIN BOARD, COMPLETE (E, EA, SP, TW)
MAIN BOARD, COMPLETE (E51)
255
256
A-4752-876-A MAIN BOARD, COMPLETE (AUS)
1-769-943-11 WIRE (FLAT TYPE) (11 CORE)
(EXCEPT AEP, UK)
1-773-007-11 WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
1-827-222-11 WIRE (FLAT TYPE) (19 CORE)
3-970-608-11 SUMITITE (B3), +BV
256
257
258
0 259
0 259
52
1-696-571-11 CORD, POWER (EA)
1-757-140-11 CORD, POWER (AEP, E51, SP)
Remark
Ref. No.
Part No.
Description
0 259
0 259
0 259
0 259
260
1-775-787-62
1-775-790-42
1-827-226-21
1-827-597-11
1-400-285-11
CORD, POWER (UK)
CORD, POWER (AUS)
CORD, POWER (E)
CORD, POWER (TW)
F-BEAD, E2515MRT
Remark
C911
1-162-282-31 CERAMIC
100PF
10%
C912
1-162-282-31 CERAMIC
100PF
10%
C913
1-128-821-11 CERAMIC
1000PF
5%
C950
0 PT002
1-128-815-11 CERAMIC
330PF
5%
1-439-845-11 TRANSFORMER, POWER (AEP, UK)
0 PT002
0 PT004
0 PT004
#1
#2
1-443-050-11
1-439-928-11
1-439-931-11
7-685-647-79
7-685-872-09
50V
(AEP, UK)
50V
(AEP, UK)
50V
(AEP, UK)
50V
TRANSFORMER, POWER (AUS)
TRANSFORMER, POWER (E, E51, SP, TW)
TRANSFORMER, POWER (EA)
SCREW +BVTP 3X10 TYPE2 N-S
SCREW +BVTT 3X8 (S)
CX-JN10
7-7. CD MECHANISM DECK SECTION-1
(CDM74S-K6BD72)
502
502
505
503
504
502
507
506
501
515
508
514
516
513
M741
515
509
516
514
513
510
512
511
503
CD mechanism deck section -2
Ref. No.
Part No.
Description
501
502
503
504
505
4-243-815-01
4-218-252-61
4-218-253-21
1-687-132-12
4-243-819-01
TABLE (LOADING)
SCREW (+PTPWH M2.6), FLOATING
SCREW (M2.6), +BTTP
SENSOR BOARD
GEAR (GENEVA)
506
507
508
509
4-243-820-01
4-243-823-01
4-243-821-01
1-776-182-11
GEAR (TABLE)
BELT (TABLE)
PULLEY (TABLE)
WIRE (FLAT TYPE) (5 CORE)
Remark
Ref. No.
Part No.
Description
510
511
512
513
514
1-687-134-12
4-243-816-01
3-231-598-01
4-245-570-01
4-245-571-02
MOTOR (TB) BOARD
TRAY
SHEET (BA)
GEAR (JOINT)
GEAR (STOPPER)
515
516
M741
4-985-672-01 SCREW (+PTPWH M2.6), FLOATING
4-245-572-01 BUSHING (GEAR)
A-4723-963-A MOTOR ASSY, TABLE
Remark
53
CX-JN10
7-8. CD MECHANISM DECK SECTION-2
(CDM74S-K6BD72)
559
562
551
560
551
558
564
554
561
565
S711
563
M751
CD mechanism deck section -3
556
557
553
555
552
554
551
Ref. No.
Part No.
Description
551
552
553
554
555
4-218-252-61
4-244-034-01
4-224-613-01
4-218-253-31
1-687-669-12
SCREW (+PTPWH M2.6), FLOATING
BELT (LOADING)
GEAR (SHAFT)
SCREW (M2.6), +BTTP
SW BOARD
556
557
558
559
1-687-135-12
4-225-844-01
4-224-611-01
4-224-609-01
DRIVER BOARD
GEAR (LOADING A)
GEAR (LOADING B)
GEAR (LOADING C)
54
554
Remark
Ref. No.
Part No.
Description
Remark
560
561
562
563
564
3-016-533-11
4-244-108-01
4-224-608-01
1-687-133-12
4-224-606-01
WASHER (FR), STOPPER
GEAR, SWING
COLLAR, SWING
MOTOR (LD) BOARD
GEAR (RV)
565
M751
S711
4-243-818-01 GEAR (U/D)
A-4736-655-A MOTOR ASSY, LOADING
1-477-680-12 ENCODER, ROTARY
(DISC TRAY ADDRESS DETECT)
CX-JN10
7-9. CD MECHANISM DECK SECTION-3
(CDM74S-K6BD72)
603
604
605
602
601
612
606
604
BU-K6BD72
607
607
608
609
608
610
Ref. No.
Part No.
Description
601
602
603
604
605
X-4955-707-2
1-471-035-11
4-231-189-01
4-218-252-61
4-243-822-02
PULLEY (A5) ASSY, CHUCKING
MAGNET ASSY
PULLEY (B), CHUCKING
SCREW (+PTPWH M2.6), FLOATING
LEVER (LIFTER)
606
X-4955-536-1 HOLDER (213) ASSY
Remark
611
Ref. No.
Part No.
Description
607
608
609
610
611
4-227-549-11
4-227-045-31
4-231-151-01
4-218-253-31
4-985-672-01
INSULATOR
SPRING (INSULATOR), COIL
STOPPER (BU)
SCREW (M2.6), +BTTP
SCREW (+PTPWH M2.6), FLOATING
612
4-243-817-01 CHASSIS
Remark
55
CX-JN10
7-10. BASE UNIT SECTION
(BU-K6BD72)
652
not supplied
(M702)
not supplied
(M701)
653
#3
651
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
Ref. No.
Part No.
651
0 652
A-4734-406-A BD BOARD, COMPLETE
A-4735-357-A BASE ASSY, OP (KSM-213DCP)
(including M701 (SLED), M702 (SPINDLE))
56
Description
Remark
Ref. No.
653
#3
Part No.
Description
1-792-024-11 WIRE (FLAT TYPE) (16 CORE)
7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
Remark
CX-JN10
SECTION 8
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Abbreviation
AUS : Australian model
E51 : Chilean and Peruvian models
Ref. No.
Part No.
BD
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
EA : Saudi Arabia model
SP : Singapore model
Description
Remark
A-4734-406-A BD BOARD, COMPLETE
*******************
C701
C702
C703
C704
C705
1-164-156-11
1-124-584-00
1-164-156-11
1-124-589-11
1-162-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
100uF
0.1uF
47uF
0.001uF
C706
C707
C708
C709
C710
1-164-156-11
1-124-584-00
1-164-156-11
1-124-584-00
1-165-176-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
100uF
0.1uF
100uF
0.047uF
20%
10%
25V
10V
25V
10V
16V
C711
C712
C713
C714
C715
1-164-156-11
1-162-949-11
1-162-968-11
1-164-156-11
1-126-160-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
47PF
5%
0.0047uF 10%
0.1uF
1uF
20%
25V
50V
50V
25V
50V
C716
C717
C718
C719
C720
1-162-964-11
1-162-968-11
1-115-156-11
1-162-968-11
1-162-953-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.0047uF
1uF
0.0047uF
100PF
50V
50V
10V
50V
50V
C721
C722
C723
C729
C731
1-164-156-11
1-164-156-11
1-124-584-00
1-126-923-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.1uF
0.1uF
100uF
220uF
0.1uF
C732
C733
C734
C735
C741
1-162-970-11
1-162-970-11
1-162-917-11
1-162-918-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
15PF
18PF
0.1uF
C742
C743
C744
C745
C746
1-164-156-11
1-165-176-11
1-125-837-11
1-162-949-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.047uF
1uF
47PF
0.1uF
C747
C748
C750
C751
C752
1-164-156-11
1-126-923-11
1-162-949-11
1-162-949-11
1-162-949-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220uF
47PF
47PF
47PF
20%
20%
10%
25V
10V
25V
16V
50V
When indicating parts by reference
number, please include the board.
TW : Taiwan model
Ref. No.
C753
C754
C756
< CAPACITOR >
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Part No.
Description
1-162-949-11 CERAMIC CHIP
1-162-949-11 CERAMIC CHIP
1-162-949-11 CERAMIC CHIP
Remark
47PF
47PF
47PF
5%
5%
5%
50V
50V
50V
< CONNECTOR >
CN708
CN710
1-793-907-11 CONNECTOR, FFC/FPC 16P
1-784-741-11 CONNECTOR, FFC 19P
< FERRITE BEAD >
20%
FB701
FB707
FB708
1-550-907-21 BEAD, FERRITE (CHIP) (2012)
1-550-907-21 BEAD, FERRITE (CHIP) (2012)
1-550-907-21 BEAD, FERRITE (CHIP) (2012)
< IC >
10%
10%
10%
5%
20%
20%
10%
10%
5%
5%
10%
10%
5%
20%
5%
5%
5%
25V
25V
10V
10V
25V
25V
25V
50V
50V
25V
25V
16V
6.3V
50V
25V
25V
10V
50V
50V
50V
IC721
IC722
6-701-796-01 IC LC78646E-E
6-704-220-01 IC BA5836FP
< TRANSISTOR >
Q701
8-729-054-57 TRANSISTOR
KTN2907AS-RTK
< RESISTOR >
R701
R702
R703
R704
R705
1-216-841-11
1-216-835-11
1-216-835-11
1-216-835-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
15K
15K
15K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R706
R707
R708
R709
R711
1-216-841-11
1-216-797-11
1-216-833-11
1-216-838-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10
10K
27K
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R713
R714
R715
R716
R717
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R718
R719
R720
R721
R722
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R725
1-216-819-11 METAL CHIP
680
5%
1/10W
57
CX-JN10
BD
Ref. No.
CD KEY
DRIVER
HP
Part No.
Description
R726
R727
R728
R729
1-216-819-11
1-216-809-11
1-216-841-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
100
47K
12K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Remark
R730
R731
R732
R738
R739
1-216-822-11
1-216-825-11
1-216-864-11
1-218-867-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
1.2K
2.2K
0
6.8K
0
5%
5%
1/10W
1/10W
0.5%
1/10W
R740
R741
R744
R745
R746
1-218-867-11
1-216-864-11
1-216-845-11
1-216-809-11
1-216-803-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
0
100K
100
33
0.5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R747
R751
R752
R753
R754
1-216-803-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R760
R765
1-216-809-11 METAL CHIP
1-216-857-11 METAL CHIP
100
1M
5%
5%
1/10W
1/10W
Ref. No.
C741
C751
C752
Part No.
Description
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-164-159-21 CERAMIC
Remark
0.01uF
0.01uF
0.1uF
20%
20%
16V
16V
50V
< CONNECTOR >
CN701
CN702
* CN703
CN704
1-785-338-11
1-784-766-11
1-564-720-11
1-785-328-11
PIN, CONNECTOR (LIGHT ANGLE) 12P
CONNECTOR, FFC 5P
PIN, CONNECTOR (SMALL TYPE) 4P
PIN, CONNECTOR (LIGHT ANGRE) 2P
< DIODE >
D701
D711
8-719-921-42 DIODE MTZJ-5.1A
8-719-109-69 DIODE RD3.6ESB2
< IC >
IC701
IC712
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q731
8-729-029-66 TRANSISTOR
DTC114ESA
< RESISTOR >
< SWITCH >
S701
1-771-853-11 SWITCH, DETECTION (LIMIT IN)
< VIBRATOR >
X701
1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz)
************************************************************
1-861-661-11 CD KEY BOARD
*************
R701
R702
R711
R712
R713
1-249-413-11
1-247-807-31
1-249-417-11
1-249-425-11
1-249-433-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
100
1K
4.7K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R721
R722
R723
R731
R732
1-249-425-11
1-249-425-11
1-249-425-11
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
4.7K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< CONNECTOR >
CN302
R733
1-249-417-11 CARBON
1K
5%
1/4W
R734
1-249-430-11 CARBON
12K
5%
1/4W
R735
1-247-807-31 CARBON
100
5%
1/4W
R751
1-249-425-11 CARBON
4.7K
5%
1/4W
************************************************************
1-784-766-11 CONNECTOR, FFC 5P
< RESISTOR >
R326
R327
R328
R329
1-216-822-11
1-216-824-11
1-216-824-11
1-216-826-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
1.8K
1.8K
2.7K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1-688-400-15 HP BOARD
*********
< CAPACITOR >
< SWITCH >
C250
S319
1-762-875-21 SWITCH, KEYBOARD (OPEN/CLOSE Z)
S320
1-762-875-21 SWITCH, KEYBOARD (DISC DIRECT PLAY 3)
S321
1-762-875-21 SWITCH, KEYBOARD (DISC DIRECT PLAY 2)
S322
1-762-875-21 SWITCH, KEYBOARD (DISC DIRECT PLAY 1)
S323
1-762-875-21 SWITCH, KEYBOARD (DISC CHANGE)
************************************************************
1-687-135-12 DRIVER BOARD
*************
1-125-891-11 CERAMIC CHIP
0.47uF
10%
5%
1/8W
5%
1/8W
5%
1/2W
(EXCEPT AEP, UK)
5%
1/2W
(EXCEPT AEP, UK)
5%
1/2W
(EXCEPT AEP, UK)
< JACK >
J221
1-785-448-21 JACK (PHONES)
< RESISTOR >
R221
R222
R223
1-216-206-00 RES-CHIP
1-216-206-00 RES-CHIP
1-260-089-11 CARBON
2.2K
2.2K
150
R224
1-260-089-11 CARBON
150
R225
1-260-089-11 CARBON
150
R225
1-260-090-61 CARBON
180
< CAPACITOR >
C715
C731
C735
C736
C737
58
1-126-933-11
1-126-964-11
1-164-159-21
1-164-159-21
1-164-159-21
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
100uF
10uF
0.1uF
0.1uF
0.1uF
20%
20%
16V
50V
50V
50V
50V
10V
5%
1/2W
(AEP, UK)
CX-JN10
HP
Ref. No.
Part No.
Description
Remark
R226
1-260-089-11 CARBON
150
R226
1-260-090-61 CARBON
180
5%
1/2W
(EXCEPT AEP, UK)
5%
1/2W
(AEP, UK)
Ref. No.
Part No.
KEY
Description
Remark
< FERRITE BEAD >
FB401
1-410-396-41 FERRITE
0.45uH (EXCEPT AEP, UK)
< IC >
< WIRE HOLDER >
IC401
8-759-710-97 IC NJM4565M-D (EXCEPT AEP, UK)
WH230 1-816-818-11 HOLDER, WIRE 5P
************************************************************
A-4732-748-A KEY BOARD, COMPLETE (E51)
A-4732-922-A KEY BOARD, COMPLETE (AEP, UK)
A-4734-690-A KEY BOARD, COMPLETE (E, EA, SP, TW, AUS)
********************
J401
C402
1-164-156-11 CERAMIC CHIP
25V
(EXCEPT AEP, UK)
0.0047uF 10%
50V
(EXCEPT AEP, UK)
0.22uF
20%
50V
(EXCEPT AEP, UK)
1uF
20%
50V
(EXCEPT AEP, UK)
220uF
20%
10V
(EXCEPT AEP, UK)
C403
1-162-968-11 CERAMIC CHIP
C404
1-126-957-11 ELECT
C405
1-126-960-11 ELECT
C406
1-126-923-11 ELECT
C407
1-162-926-11 CERAMIC CHIP
82PF
C408
1-126-956-11 ELECT
0.1uF
C409
1-126-934-11 ELECT
220uF
C410
1-126-965-11 ELECT
22uF
C411
1-164-473-11 CERAMIC CHIP
820PF
C412
1-126-960-11 ELECT
1uF
C416
1-126-956-11 ELECT
0.1uF
C419
1-164-156-11 CERAMIC CHIP
0.1uF
C441
1-100-597-11 CERAMIC CHIP
0.1uF
C801
1-162-964-11 CERAMIC CHIP
0.001uF
20%
50V
(EXCEPT AEP, UK)
20%
50V
(EXCEPT AEP, UK)
25V
(EXCEPT AEP, UK)
10%
25V
(EXCEPT AEP, UK)
10%
50V
C802
C803
C804
C805
C806
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C807
C808
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
0.001uF
0.001uF
10%
10%
50V
50V
1-816-860-11 JACK, 6.3 BLK MONO W/SW V MSC (MIC)
(EXCEPT AEP, UK)
< SHORT >
JR403
JR404
< CAPACITOR >
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
0 (EXCEPT AEP, UK)
0 (EXCEPT AEP, UK)
0.1uF
5%
50V
(EXCEPT AEP, UK)
20%
50V
(EXCEPT AEP, UK)
20%
16V
(EXCEPT AEP, UK)
20%
50V
(EXCEPT AEP, UK)
5%
50V
(EXCEPT AEP, UK)
< CONNECTOR >
CN301
CN303
< JACK >
1-784-766-11 CONNECTOR, FFC 5P
1-784-784-11 CONNECTOR, FFC 23P
< LED >
LED201 8-719-053-43 LED SLR-325VCT31 (i-BASS)
LED901 6-500-641-01 LED SLI-325URC (1 STANDBY/ON)
< FET >
Q401
8-729-045-62 FET
2SK2158-T2B
(EXCEPT AEP, UK)
< RESISTOR >
R231
R301
R302
R303
R304
1-216-198-00
1-216-864-11
1-216-821-11
1-216-820-11
1-216-821-11
RES-CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
1K
820
1K
5%
1/8W
5%
5%
5%
1/10W
1/10W
1/10W
R305
R306
R311
R312
R313
1-216-822-11
1-216-822-11
1-216-864-11
1-216-821-11
1-216-820-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
1.2K
1.2K
0
1K
820
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R314
R315
R316
R317
R318
1-216-821-11
1-216-822-11
1-216-822-11
1-216-824-11
1-216-824-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1.2K
1.2K
1.8K
1.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R321
R322
R323
R324
R325
1-216-864-11
1-216-821-11
1-216-820-11
1-216-821-11
1-216-822-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
1K
820
1K
1.2K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R401
1-216-845-11 METAL CHIP
100K
R402
1-216-829-11 METAL CHIP
4.7K
R403
1-216-849-11 METAL CHIP
220K
R404
1-218-867-11 METAL CHIP
6.8K
R405
1-216-825-11 METAL CHIP
2.2K
R406
1-216-850-11 METAL CHIP
270K
R407
1-216-825-11 METAL CHIP
2.2K
< DIODE >
D401
8-719-991-33 DIODE 1SS133T-77 (EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
0.5% 1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
59
CX-JN10
KEY
Ref. No.
MAIN
Part No.
Description
Remark
R408
1-216-174-00 RES-CHIP
100
R409
1-216-825-11 METAL CHIP
2.2K
R410
1-216-825-11 METAL CHIP
2.2K
R411
1-216-825-11 METAL CHIP
2.2K
R412
1-216-825-11 METAL CHIP
2.2K
R413
1-216-839-11 METAL CHIP
33K
R414
1-216-797-11 METAL CHIP
10
R432
1-216-833-11 METAL CHIP
10K
5%
1/8W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
R801
R802
R803
R804
R805
1-216-833-11
1-216-833-11
1-216-797-11
1-216-797-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10
10
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R806
R807
R808
R809
R810
1-216-833-11
1-216-797-11
1-216-797-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10
10
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R811
R812
R813
R814
R815
1-216-797-11
1-216-797-11
1-216-833-11
1-216-833-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
10
10K
10K
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R816
1-216-797-11 METAL CHIP
10
5%
1/10W
Ref. No.
Part No.
Description
Remark
< VARIABLE RESISTOR >
VR401
1-227-502-11 RES, VAR, CARBON 10K (MIC MIXING)
(EXCEPT AEP, UK)
************************************************************
A-4752-863-A
A-4752-871-A
A-4752-874-A
A-4752-876-A
MAIN BOARD, COMPLETE (AEP, UK)
MAIN BOARD, COMPLETE (E, EA, SP, TW)
MAIN BOARD, COMPLETE (E51)
MAIN BOARD, COMPLETE (AUS)
*********************
< CAPACITOR/SHORT >
C003
1-126-974-21 ELECT
3300uF
C003
1-127-811-11 ELECT
3300uF
C004
1-126-974-21 ELECT
3300uF
C004
1-127-811-11 ELECT
3300uF
C005
1-126-944-11 ELECT
3300uF
C005
1-126-955-21 ELECT
4700uF
C006
1-126-944-11 ELECT
3300uF
C006
1-126-955-21 ELECT
4700uF
C007
1-126-944-11 ELECT
3300uF
C007
1-128-549-11 ELECT
3300uF
C008
C011
1-126-942-61 ELECT
1-165-621-11 CERAMIC CHIP
1000uF
0.1uF
C012
1-165-621-11 CERAMIC CHIP
0.1uF
C013
1-165-621-11 CERAMIC CHIP
0.1uF
C014
1-165-621-11 CERAMIC CHIP
0.1uF
20%
50V
(E, EA, SP, TW, AUS)
20%
50V
(E51)
20%
50V
(E, EA, SP, TW, AUS)
20%
50V
(E51)
20%
25V
(AEP, UK)
< SWITCH/ROTART ENCODER >
20%
35V
(EXCEPT AEP, UK)
20%
25V
(AEP, UK)
20%
35V
(EXCEPT AEP, UK)
20%
25V
(AEP, UK)
20%
35V
(EXCEPT AEP, UK)
20%
25V
50V
(EXCEPT AEP, UK)
50V
(EXCEPT AEP, UK)
50V
(EXCEPT AEP, UK)
50V
(EXCEPT AEP, UK)
S301
S302
S303
S304
S305
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (PLAY/PRESET N)
SWITCH, KEYBOARD (STOP/CLEAR x)
SWITCH, KEYBOARD (TUNING DOWN m)
SWITCH, KEYBOARD (PAUSE/SET X)
SWITCH, KEYBOARD (TUNING DOWN M)
S306
S307
S308
S309
S310
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (i-BASS)
SWITCH, KEYBOARD (MODE)
SWITCH, KEYBOARD (ENTER)
SWITCH, KEYBOARD (CD)
SWITCH, KEYBOARD (TAPE A/B)
C015
C016
C017
C018
C022
1-165-621-11
1-165-621-11
1-165-621-11
1-165-621-11
1-126-933-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.1uF
100uF
20%
50V
50V
50V
50V
16V
S311
S312
S313
S314
S315
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (TUNER, BAND)
SWITCH, KEYBOARD (VIDEO/AUX)
SWITCH, KEYBOARD (z REC, REC MUTING)
SWITCH, KEYBOARD (SYNC DUB)
SWITCH, KEYBOARD (POWER)
C023
C026
C029
C030
C031
1-126-948-11
1-126-947-11
1-126-947-11
1-162-968-11
1-126-947-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
100uF
47uF
47uF
0.0047uF
47uF
20%
20%
20%
10%
20%
35V
35V
35V
50V
35V
S317
S318
S801
S802
S803
1-762-875-21
1-762-875-21
1-786-396-11
1-786-396-11
1-477-824-11
SWITCH, KEYBOARD (PTY) (AEP, UK)
SWITCH, KEYBOARD (RT) (AEP, UK)
SWITCH, ROTARY (ENCODER) (VOLUME)
SWITCH, ROTARY (ENCODER) (BASS)
ENCODER, ROTARY (TREBLE)
C032
C033
1-104-663-11 ELECT
1-165-621-11 CERAMIC CHIP
33uF
0.1uF
20%
C034
1-165-621-11 CERAMIC CHIP
0.1uF
S804
1-786-418-11 SWITCH, ROTARY (ENCODER) (MULTI JOG)
C035
C041
1-164-156-11 CERAMIC CHIP
1-126-948-11 ELECT
0.1uF
100uF
C041
1-126-964-11 ELECT
10uF
60
25V
50V
(EXCEPT AEP, UK)
50V
(EXCEPT AEP, UK)
25V
20%
35V
(AEP, UK)
20%
50V
(EXCEPT AEP, UK)
CX-JN10
MAIN
Ref. No.
Part No.
Description
Remark
C042
1-126-948-11 ELECT
100uF
C042
1-126-964-11 ELECT
10uF
C043
1-126-948-11 ELECT
100uF
C043
1-126-964-11 ELECT
10uF
Remark
100PF
5%
C130
1-100-152-11 CERAMIC CHIP
100PF
5%
C131
1-162-927-11 CERAMIC CHIP
100PF
5%
C132
1-162-927-11 CERAMIC CHIP
100PF
5%
20%
C133
C134
C135
C136
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0 (AEP, UK)
0 (AEP, UK)
0 (AEP, UK)
0 (AEP, UK)
C181
C182
C201
C202
C203
1-124-252-00
1-124-252-00
1-165-621-11
1-165-621-11
1-165-621-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.33uF
0.33uF
0.1uF
0.1uF
0.1uF
C204
C205
1-165-621-11 CERAMIC CHIP
1-162-974-11 CERAMIC CHIP
0.1uF
0.01uF
C206
1-162-974-11 CERAMIC CHIP
0.01uF
C207
1-162-970-11 CERAMIC CHIP
0.01uF
10%
C208
1-162-970-11 CERAMIC CHIP
0.01uF
10%
C209
C210
C230
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
1-128-582-11 ELECT
C231
1-128-582-11 ELECT
C232
1-164-156-11 CERAMIC CHIP
0 (AEP, UK)
0 (AEP, UK)
10uF
20%
100V
(EXCEPT AEP, UK)
10uF
20%
100V
(EXCEPT AEP, UK)
0.1uF
25V
(EXCEPT AEP, UK)
C241
C281
C282
C301
C302
1-125-891-11
1-162-968-11
1-162-966-11
1-164-647-11
1-164-647-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
0.0047uF
0.0022uF
0.0012uF
0.0012uF
10%
10%
10%
10%
10%
10V
50V
50V
50V
50V
C303
C304
C305
C306
C311
1-164-647-11
1-164-647-11
1-162-962-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0012uF
0.0012uF
470PF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C312
C313
C314
C315
C316
1-162-964-11
1-162-962-11
1-162-962-11
1-130-487-00
1-130-485-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
MYLAR
0.001uF
470PF
470PF
0.022uF
0.015uF
10%
10%
10%
5%
5%
50V
50V
50V
50V
50V
C317
C318
C319
C320
C321
1-130-485-00
1-130-479-00
1-126-964-11
1-164-156-11
1-164-156-11
MYLAR
MYLAR
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.015uF 5%
0.0047uF 5%
10uF
20%
0.1uF
0.1uF
50V
50V
50V
25V
25V
C322
C601
C602
C603
C604
1-164-156-11
1-162-923-11
1-162-923-11
1-104-658-11
1-104-658-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
47PF
47PF
100uF
100uF
25V
50V
50V
10V
10V
100uF
C044
1-126-964-11 ELECT
10uF
C045
C046
C047
1-126-968-11 ELECT
1-126-968-11 ELECT
1-104-658-11 ELECT
100uF
100uF
100uF
C061
C062
C063
C097
C103
1-126-947-11
1-126-960-11
1-126-960-11
1-164-156-11
1-163-137-00
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
47uF
1uF
1uF
0.1uF
680PF
20%
20%
20%
C103
1-163-139-00 CERAMIC CHIP
820PF
C104
1-163-137-00 CERAMIC CHIP
680PF
C104
1-163-139-00 CERAMIC CHIP
820PF
C105
C106
1-126-961-11 ELECT
1-126-961-11 ELECT
2.2uF
2.2uF
5%
50V
(EXCEPT AEP, UK)
5%
50V
(AEP, UK)
5%
50V
(EXCEPT AEP, UK)
20%
50V
20%
50V
C109
C110
C111
1-126-964-11 ELECT
1-126-964-11 ELECT
1-162-927-11 CERAMIC CHIP
10uF
10uF
100PF
20%
20%
5%
C112
1-162-927-11 CERAMIC CHIP
100PF
5%
C113
1-126-966-11 ELECT
33uF
20%
C114
C115
C116
C117
1-126-966-11
1-163-139-00
1-163-139-00
1-100-152-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33uF
820PF
820PF
100PF
C117
1-162-927-11 CERAMIC CHIP
100PF
20%
50V
5%
50V
5%
50V
5%
100V
(EXCEPT AEP, UK)
5%
50V
(AEP, UK)
C118
1-100-152-11 CERAMIC CHIP
100PF
C118
1-162-927-11 CERAMIC CHIP
C119
1-100-152-11 CERAMIC CHIP
C119
C120
1-216-864-11 SHORT CHIP
1-100-152-11 CERAMIC CHIP
SHORT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
Description
1-100-152-11 CERAMIC CHIP
1-126-948-11 ELECT
1-216-864-11
1-165-621-11
1-165-621-11
1-162-970-11
1-162-970-11
Part No.
C129
C044
C120
C121
C122
C125
C126
Ref. No.
35V
(AEP, UK)
20%
50V
(EXCEPT AEP, UK)
20%
35V
(AEP, UK)
20%
50V
(EXCEPT AEP, UK)
20%
35V
(AEP, UK)
20%
50V
(EXCEPT AEP, UK)
20%
50V
20%
50V
20%
10V
5%
35V
50V
50V
25V
50V
(AEP, UK)
50V
50V
50V
(AEP, UK)
50V
(AEP, UK)
50V
5%
100V
(EXCEPT AEP, UK)
100PF
5%
50V
(AEP, UK)
100PF
5%
100V
(EXCEPT AEP, UK)
0 (AEP, UK)
100PF
5%
100V
(EXCEPT AEP, UK)
0 (AEP, UK)
0.1uF
0.1uF
0.01uF
10%
0.01uF
10%
C127
1-100-152-11 CERAMIC CHIP
100PF
5%
C128
1-100-152-11 CERAMIC CHIP
100PF
5%
50V
50V
25V
25V
100V
(AEP, UK)
100V
(AEP, UK)
20%
20%
5%
5%
20%
20%
100V
(AEP, UK)
100V
(AEP, UK)
50V
(AEP, UK)
50V
(AEP, UK)
50V
50V
50V
50V
50V
50V
50V
(AEP, UK)
50V
(AEP, UK)
25V
(AEP, UK)
25V
(AEP, UK)
61
CX-JN10
MAIN
Ref. No.
Part No.
Description
C605
C606
C607
C608
C609
1-130-481-00
1-130-481-00
1-162-962-11
1-162-962-11
1-126-960-11
MYLAR
MYLAR
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.0068uF
0.0068uF
470PF
470PF
1uF
5%
5%
10%
10%
20%
50V
50V
50V
50V
50V
Remark
C610
C611
C612
C613
C614
1-126-960-11
1-164-739-11
1-164-739-11
1-162-967-11
1-162-967-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
560PF
560PF
0.0033uF
0.0033uF
20%
5%
5%
10%
10%
50V
50V
50V
50V
50V
C621
C622
C623
C624
C625
1-164-218-11
1-164-218-11
1-164-479-11
1-164-479-11
1-164-174-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
180PF
180PF
0.0056uF
0.0056uF
0.0082uF
5%
5%
10%
10%
10%
50V
50V
50V
50V
25V
C626
C641
C642
C643
C644
1-164-174-11
1-126-957-11
1-126-957-11
1-126-957-11
1-126-957-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
0.0082uF
0.22uF
0.22uF
0.22uF
0.22uF
10%
20%
20%
20%
20%
25V
50V
50V
50V
50V
C651
C652
C653
C654
C655
1-162-964-11
1-162-964-11
1-162-959-11
1-162-927-11
1-162-959-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
330PF
100PF
330PF
10%
10%
5%
5%
5%
50V
50V
50V
50V
50V
C661
C662
C663
C664
C684
1-126-923-11
1-126-947-11
1-164-156-11
1-164-156-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
47uF
0.1uF
0.1uF
0.1uF
20%
20%
10V
35V
25V
25V
25V
C685
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C686
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C687
C693
C694
1-162-974-11 CERAMIC CHIP
1-126-960-11 ELECT
1-126-960-11 ELECT
0.01uF
1uF
1uF
C695
C698
1-126-925-11 ELECT
1-162-974-11 CERAMIC CHIP
470uF
0.01uF
C699
1-162-974-11 CERAMIC CHIP
0.01uF
C730
C731
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
100PF
100PF
5%
5%
C732
C733
1-162-927-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
100PF
0.1uF
5%
C734
1-164-156-11 CERAMIC CHIP
0.1uF
C801
1-126-964-11 ELECT
10uF
C802
1-164-156-11 CERAMIC CHIP
0.1uF
C910
1-162-974-11 CERAMIC CHIP
0.01uF
20%
20%
20%
20%
< CONNECTOR >
* CN301
* CN302
62
1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P
50V
(AEP, UK)
50V
(AEP, UK)
50V
50V
50V
10V
50V
(AEP, UK)
50V
(AEP, UK)
50V
50V
50V
25V
(AEP, UK)
25V
(AEP, UK)
50V
(AEP, UK)
25V
(AEP, UK)
50V
(AEP, UK)
Ref. No.
Part No.
Description
Remark
CN601
CN691
CN694
1-793-766-11 CONNECTOR, BOARD TO BOARD 30P
1-784-780-11 CONNECTOR, FFC 19P
1-568-830-11 CONNECTOR, FFC 11P
CN801
CN802
1-568-830-11 CONNECTOR, FFC 11P (EXCEPT AEP, UK)
1-784-776-11 CONNECTOR, FFC 15P (AEP, UK)
< DIODE/SHORT >
D009
D015
D016
D017
D018
8-719-072-05
6-500-802-01
6-500-802-01
6-500-802-01
6-500-802-01
DIODE
DIODE
DIODE
DIODE
DIODE
RBV-602LF-A (EXCEPT AEP, UK)
1N5402-E7
1N5402-E7
1N5402-E7
1N5402-E7
D019
D020
D021
D022
D023
8-719-048-61
8-719-048-61
8-719-048-61
8-719-048-61
8-719-085-36
DIODE
DIODE
DIODE
DIODE
DIODE
EGP20DL-6349
EGP20DL-6349
EGP20DL-6349 (EXCEPT AEP, UK)
EGP20DL-6349 (EXCEPT AEP, UK)
11EQS04-TB5
D031
D032
D033
D041
D042
8-719-988-61
8-719-988-61
8-719-988-61
6-500-522-21
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
10EDB40-TB3
10EDB40-TB3
D043
D044
D045
D063
D064
6-500-522-21
6-500-522-21
8-719-083-70
6-500-334-01
6-500-335-01
DIODE
DIODE
DIODE
DIODE
DIODE
10EDB40-TB3
10EDB40-TB3
UDZSTE-1727B
MC2836 (EXCEPT AEP, UK)
MC2838 (EXCEPT AEP, UK)
D065
D066
D067
D068
D069
8-719-988-61
8-719-988-61
6-500-335-01
6-500-334-01
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17 (EXCEPT AEP, UK)
1SS355TE-17 (EXCEPT AEP, UK)
MC2838 (EXCEPT AEP, UK)
MC2836 (EXCEPT AEP, UK)
1SS355TE-17
D101
D103
D104
D105
D106
6-500-334-01
8-719-988-61
8-719-988-61
6-500-334-01
6-500-334-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2836
1SS355TE-17
1SS355TE-17
MC2836
MC2836
D107
D108
D109
D110
D111
6-500-335-01
6-500-335-01
8-719-046-74
8-719-046-74
6-500-335-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2838
MC2838
AU-01Z-V1
AU-01Z-V1
MC2838 (EXCEPT AEP, UK)
D231
D232
D235
D236
D239
8-719-988-61
8-719-977-28
8-719-059-21
8-719-059-21
8-719-069-55
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17 (EXCEPT AEP, UK)
DTZ10B (EXCEPT AEP, UK)
RK46LF-T2 (EXCEPT AEP, UK)
RK46LF-T2 (EXCEPT AEP, UK)
UDZSTE-175.6B (EXCEPT AEP, UK)
D240
D241
D242
D243
D244
8-719-069-55
8-719-988-61
1-216-295-00
6-500-335-01
6-500-334-01
DIODE UDZSTE-175.6B (EXCEPT AEP, UK)
DIODE 1SS355TE-17 (EXCEPT AEP, UK)
SHORT CHIP
0 (EXCEPT AEP, UK)
DIODE MC2838 (EXCEPT AEP, UK)
DIODE MC2836 (EXCEPT AEP, UK)
D281
D291
D292
D301
D661
6-500-335-01
6-500-334-01
6-500-335-01
6-500-334-01
8-719-083-60
DIODE
DIODE
DIODE
DIODE
DIODE
MC2838
MC2836
MC2838
MC2836
UDZSTE-174.7B
CX-JN10
MAIN
Ref. No.
Remark
Ref. No.
Part No.
Description
D662
D663
D671
D691
D692
8-719-083-60
8-719-988-61
8-719-988-61
6-500-522-21
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
UDZSTE-174.7B
1SS355TE-17
1SS355TE-17
10EDB40-TB3
10EDB40-TB3
JR651
JR701
JR801
D693
D694
D695
D697
D801
6-500-522-21
6-500-522-21
8-719-988-61
6-500-522-21
8-719-069-54
DIODE
DIODE
DIODE
DIODE
DIODE
10EDB40-TB3
10EDB40-TB3
1SS355TE-17
10EDB40-TB3
UDZSTE-175.1B (AEP, UK)
JW690
Description
1-216-296-11 SHORT CHIP
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
Remark
0
0
0 (EXCEPT AEP, UK)
< DIODE >
6-500-522-21 DIODE 10EDB40-TB3
< COIL >
L201
L201
L202
L202
L311
< EARTH TERMINAL >
* EP001
* EP099
Part No.
1-537-738-21 TERMINAL, EARTH
1-537-738-21 TERMINAL, EARTH
1-422-009-13
1-456-107-11
1-422-009-13
1-456-107-11
1-424-849-11
COIL, AIR-CORE (AEP, UK)
COIL, AIR-CORE (EXCEPT AEP, UK)
COIL, AIR-CORE (AEP, UK)
COIL, AIR-CORE (EXCEPT AEP, UK)
COIL, OSCILLATION (BIAS)
< TRANSISTOR >
< SHORT/FERRITE BEAD >
FB601
FB602
FB693
IC001
IC002
IC003
IC601
IC672
J203
J602
Q022
Q023
Q024
Q041
8-729-120-28
8-729-201-53
8-729-120-28
8-729-201-53
< IC >
Q043
8-729-201-53 TRANSISTOR
2SC1623-L5L6
2SA1015-GR
2SC1623-L5L6
2SA1015-GR
(EXCEPT AEP, UK)
2SA1015-GR
IC
IC
IC
IC
IC
NJM78M09FA
NJM78M09FA
TA7804LS
BD3881FV
BU2092F-E2
Q045
Q046
Q047
Q063
Q064
8-729-120-28
8-729-120-28
8-729-120-28
8-729-600-22
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SA1235-F
2SC1623-L5L6
< TERMINAL/JACK >
Q101
Q102
Q103
Q104
Q105
8-729-600-22
8-729-600-22
8-729-600-22
8-729-600-22
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1235-F
2SA1235-F
2SA1235-F
2SA1235-F
2SC1623-L5L6
Q106
Q107
Q108
Q109
8-729-120-28
8-729-120-28
8-729-120-28
6-550-317-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q110
6-550-317-01 TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SD0814A0LS0
(EXCEPT AEP, UK)
2SD0814A0LS0
(EXCEPT AEP, UK)
Q111
Q112
Q117
Q118
Q119
8-729-823-99
8-729-823-99
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2909-AA
2SC2909-AA
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
Q120
Q121
Q121
Q122
Q122
8-729-120-28
6-550-294-01
6-550-331-01
6-550-294-01
6-550-331-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SB1342 (AEP, UK)
2SB1677 (EXCEPT AEP, UK)
2SB1342 (AEP, UK)
2SB1677 (EXCEPT AEP, UK)
Q123
Q123
Q124
Q124
Q129
6-550-295-01
6-550-332-01
6-550-295-01
6-550-332-01
6-550-316-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1933 (AEP, UK)
2SD2619 (EXCEPT AEP, UK)
2SD1933 (AEP, UK)
2SD2619 (EXCEPT AEP, UK)
2SB0792A0LS0
(EXCEPT AEP, UK)
Q129
Q130
8-729-600-22 TRANSISTOR
6-550-316-01 TRANSISTOR
Q130
Q181
8-729-600-22 TRANSISTOR
8-729-052-79 TRANSISTOR
2SA1235-F (AEP, UK)
2SB0792A0LS0
(EXCEPT AEP, UK)
2SA1235-F (AEP, UK)
2SD1306NETL
1-216-295-00 SHORT CHIP
1-216-295-00 SHORT CHIP
1-410-396-71 FERRITE BEAD
8-759-701-59
8-759-701-59
6-703-546-01
6-702-895-01
8-759-396-78
0
0
0.45uH
1-694-635-12 TERMINAL BOARD (4P) (SPEAKER)
1-793-987-11 JACK, PIN 2P (VIDEO/AUX)
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
< RESISTOR >
JR001
JR002
JR104
JR201
JR202
1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR203
JR204
JR601
JR602
JR603
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0 (AEP, UK)
0
0
JR604
JR605
JR606
JR607
JR608
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR609
JR610
JR611
JR612
JR615
1-216-821-11
1-216-821-11
1-216-296-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
1K
5%
1K
5%
0 (AEP, UK)
0
0
JR616
JR619
JR620
JR622
JR623
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR625
1-216-296-11 SHORT CHIP
0
1/10W
1/10W
63
CX-JN10
MAIN
Ref. No.
Part No.
Description
Remark
Q182
8-729-052-79 TRANSISTOR
2SD1306NETL
Q183
Q231
Q232
Q233
8-729-600-22
6-550-293-01
6-550-293-01
8-729-600-22
Q234
8-729-120-28 TRANSISTOR
2SA1235-F
2SK2937 (EXCEPT AEP, UK)
2SK2937 (EXCEPT AEP, UK)
2SA1235-F
(EXCEPT AEP, UK)
2SC1623-L5L6
(EXCEPT AEP, UK)
TRANSISTOR
FET
FET
TRANSISTOR
Q235
8-729-600-22 TRANSISTOR
2SA1235-F
(EXCEPT AEP, UK)
2SB0792A0LS0
(EXCEPT AEP, UK)
2SA1235-F (AEP, UK)
2SD0814A0LS0
(EXCEPT AEP, UK)
2SC1623-L5L6 (AEP, UK)
Q281
6-550-316-01 TRANSISTOR
Q281
Q282
8-729-600-22 TRANSISTOR
6-550-317-01 TRANSISTOR
Q282
8-729-120-28 TRANSISTOR
Q291
Q292
8-729-027-23 TRANSISTOR
6-550-316-01 TRANSISTOR
Q292
Q301
Q302
8-729-600-22 TRANSISTOR
6-550-290-01 FET
6-550-290-01 FET
DTA114EKA-T146
2SB0792A0LS0
(EXCEPT AEP, UK)
2SA1235-F (AEP, UK)
2SJ460
2SJ460
Q303
Q304
Q305
Q306
Q307
8-729-048-99
8-729-048-99
6-550-290-01
6-550-290-01
8-729-048-99
FET
FET
FET
FET
FET
2SK2541-T
2SK2541-T
2SJ460
2SJ460
2SK2541-T
Q308
Q309
Q310
Q311
Q312
8-729-048-99
8-729-048-99
8-729-011-92
8-729-201-53
8-729-120-28
FET
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK2541-T
2SK2541-T
2SC2001TP-K1K2
2SA1015-GR
2SC1623-L5L6
Q601
8-729-027-23 TRANSISTOR
DTA114EKA-T146
< RESISTOR >
R001
1-216-138-00 RES-CHIP
3.3
R001
1-219-397-11 RES-CHIP
1.8
R002
1-219-397-11 RES-CHIP
1.8
R004
1-216-138-00 RES-CHIP
3.3
R004
1-219-397-11 RES-CHIP
1.8
R005
1-216-138-00 RES-CHIP
3.3
R005
1-219-397-11 RES-CHIP
1.8
R007
1-219-397-11 RES-CHIP
1.8
R008
1-216-138-00 RES-CHIP
3.3
R008
1-219-397-11 RES-CHIP
1.8
R009
1-216-228-00 RES-CHIP
18K
R010
1-216-228-00 RES-CHIP
18K
R011
1-216-228-00 RES-CHIP
18K
5%
1/8W
(E, EA, E51, SP, TW)
5%
1/8W
(AEP, UK, AUS)
5%
1/8W
(AEP, UK)
5%
1/8W
(E, EA, E51, SP, TW)
5%
1/8W
(AEP, UK, AUS)
5%
1/8W
(E, EA, E51, SP, TW)
5%
1/8W
(AEP, UK, AUS)
5%
1/8W
(AEP, UK)
5%
1/8W
(E, EA, E51, SP, TW)
5%
1/8W
(AEP, UK, AUS)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
Ref. No.
Part No.
Description
Remark
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
R012
1-216-228-00 RES-CHIP
18K
R013
1-216-228-00 RES-CHIP
18K
R014
1-216-228-00 RES-CHIP
18K
R015
1-216-228-00 RES-CHIP
18K
R016
1-216-228-00 RES-CHIP
18K
0 R017
1-219-121-11 FUSIBLE
0.22
0 R017
1-219-122-11 FUSIBLE
0.33
R024
R025
R026
R027
R028
1-216-184-00
1-216-184-00
1-216-188-00
1-216-188-00
1-216-186-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
270
270
390
390
330
5%
1/8W
5%
1/8W
5%
1/8W
5%
1/8W
5%
1/8W
(EXCEPT AEP, UK)
R028
1-216-188-00 RES-CHIP
390
5%
R029
R030
R031
R032
1-216-188-00
1-216-188-00
1-216-833-11
1-216-841-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
390
390
10K
47K
5%
5%
5%
5%
R033
R035
R036
R037
R038
1-216-843-11
1-216-832-11
1-216-836-11
1-216-296-11
1-216-296-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
68K
5%
8.2K
5%
18K
5%
0 (AEP, UK)
0
R041
R042
R043
R044
R045
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-178-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100K
100K
100K
100K
150
R045
R046
R047
1-216-296-11 SHORT CHIP
1-216-065-00 RES-CHIP
1-216-065-00 RES-CHIP
R047
R048
1-216-295-00 SHORT CHIP
1-216-295-00 SHORT CHIP
0 (AEP, UK)
4.7K
5%
1/10W
4.7K
5%
1/10W
(EXCEPT AEP, UK)
0 (AEP, UK)
0
R049
R050
R051
R067
1-216-065-00
1-216-001-00
1-216-097-11
1-216-843-11
4.7K
10
100K
68K
R068
1-216-843-11 METAL CHIP
68K
R069
1-216-833-11 METAL CHIP
10K
R070
1-216-838-11 METAL CHIP
27K
R071
1-216-838-11 METAL CHIP
27K
R072
1-216-830-11 METAL CHIP
5.6K
R073
1-216-838-11 METAL CHIP
27K
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/4W F
(AEP, UK)
5%
1/4W F
(EXCEPT AEP, UK)
1/8W
(AEP, UK)
1/8W
1/8W
1/10W
1/10W
1/10W
1/10W
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/8W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
64
CX-JN10
MAIN
Ref. No.
Part No.
Description
Remark
R074
1-216-838-11 METAL CHIP
27K
R075
1-216-830-11 METAL CHIP
5.6K
R076
R077
R078
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-834-11 METAL CHIP
1K
1K
12K
R078
R079
1-216-864-11 SHORT CHIP
1-216-834-11 METAL CHIP
R079
R080
R082
1-216-864-11 SHORT CHIP
1-216-845-11 METAL CHIP
1-216-839-11 METAL CHIP
0 (AEP, UK)
12K
5%
1/10W
(EXCEPT AEP, UK)
0 (AEP, UK)
100K
5%
1/10W
33K
5%
1/10W
(EXCEPT AEP, UK)
R083
1-216-839-11 METAL CHIP
33K
R084
1-216-842-11 METAL CHIP
56K
R085
1-216-842-11 METAL CHIP
56K
R086
1-216-833-11 METAL CHIP
10K
R087
1-216-833-11 METAL CHIP
10K
R092
R093
R094
R095
R096
1-216-809-11
1-216-835-11
1-216-833-11
1-216-835-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
15K
10K
15K
33K
5%
5%
5%
5%
5%
R097
R105
R106
R107
1-216-839-11
1-216-835-11
1-216-835-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
15K
15K
22K
5%
5%
5%
5%
R107
1-216-838-11 METAL CHIP
27K
R108
1-216-837-11 METAL CHIP
22K
R108
1-216-838-11 METAL CHIP
27K
R109
R110
R113
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-822-11 METAL CHIP
100
100
1.2K
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
R114
R115
1-216-822-11 METAL CHIP
1-216-081-00 RES-CHIP
1.2K
22K
5%
5%
R115
1-216-083-00 RES-CHIP
27K
R116
1-216-081-00 RES-CHIP
22K
R116
1-216-083-00 RES-CHIP
27K
R117
R118
R119
R120
R121
1-216-206-00
1-216-206-00
1-216-206-00
1-216-206-00
1-216-198-00
2.2K
2.2K
2.2K
2.2K
1K
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
R122
R123
1-216-198-00 RES-CHIP
1-218-867-11 METAL CHIP
1K
6.8K
5%
0.5%
1/8W
1/10W
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
Ref. No.
Part No.
Description
Remark
R124
R125
R126
1-218-867-11 METAL CHIP
1-216-823-11 METAL CHIP
1-216-823-11 METAL CHIP
6.8K
1.5K
1.5K
0.5%
5%
5%
1/10W
1/10W
1/10W
R127
R128
R129
R130
R131
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R132
R133
1-216-829-11 METAL CHIP
1-216-824-11 METAL CHIP
4.7K
1.8K
R133
1-216-825-11 METAL CHIP
2.2K
R134
1-216-824-11 METAL CHIP
1.8K
R134
1-216-825-11 METAL CHIP
2.2K
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
R137
R138
R139
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
1-216-841-11 METAL CHIP
2.2K
2.2K
47K
R139
R140
1-216-864-11 SHORT CHIP
1-216-841-11 METAL CHIP
R140
R141
1-216-864-11 SHORT CHIP
1-216-821-11 METAL CHIP
R141
1-216-841-11 METAL CHIP
R142
1-216-821-11 METAL CHIP
R142
1-216-841-11 METAL CHIP
R143
1-216-802-11 METAL CHIP
27
R143
1-216-804-11 METAL CHIP
39
R144
1-216-802-11 METAL CHIP
27
R144
1-216-804-11 METAL CHIP
39
R147
1-216-864-11 SHORT CHIP
0
1-216-864-11
1-245-545-11
1-245-545-11
1-245-545-11
1-245-545-11
0
0.22
0.22
0.22
0.22
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
0 (AEP, UK)
47K
5%
1/10W
(EXCEPT AEP, UK)
0 (AEP, UK)
1K
5%
1/10W
(EXCEPT AEP, UK)
47K
5%
1/10W
(AEP, UK)
1K
5%
1/10W
(EXCEPT AEP, UK)
47K
5%
1/10W
(AEP, UK)
5%
1/10W
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
R148
0 R149
0 R150
0 R151
0 R152
SHORT CHIP
METAL OXIDE
METAL OXIDE
METAL OXIDE
METAL OXIDE
R153
1-216-827-11 METAL CHIP
3.3K
R153
1-216-830-11 METAL CHIP
5.6K
R154
1-216-827-11 METAL CHIP
3.3K
R154
1-216-830-11 METAL CHIP
5.6K
R155
1-216-822-11 METAL CHIP
1.2K
R155
1-216-823-11 METAL CHIP
1.5K
R156
1-216-822-11 METAL CHIP
1.2K
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
5%
5%
5%
3W
3W
3W
3W
F
F
F
F
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
65
CX-JN10
MAIN
Ref. No.
Part No.
Description
Remark
R156
1-216-823-11 METAL CHIP
1.5K
R157
R158
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
R159
R160
R161
1-216-049-11 RES-CHIP
1-216-049-11 RES-CHIP
1-218-867-11 METAL CHIP
1K
1K
6.8K
R162
1-218-867-11 METAL CHIP
6.8K
R163
1-216-830-11 METAL CHIP
5.6K
R164
1-216-830-11 METAL CHIP
5.6K
R181
R182
R183
1-216-834-11 METAL CHIP
1-216-834-11 METAL CHIP
1-216-830-11 METAL CHIP
12K
12K
5.6K
R183
1-218-867-11 METAL CHIP
6.8K
R184
1-216-830-11 METAL CHIP
5.6K
R184
1-218-867-11 METAL CHIP
6.8K
R185
R186
R188
1-216-843-11 METAL CHIP
1-216-841-11 METAL CHIP
1-216-226-00 RES-CHIP
68K
47K
15K
R188
1-216-230-00 RES-CHIP
22K
R189
R201
R202
R203
1-216-864-11
1-249-393-11
1-249-393-11
1-216-150-11
0
10
10
10
R204
R236
1-216-150-11 RES-CHIP
1-216-861-11 METAL CHIP
10
2.2M
R237
1-216-049-11 RES-CHIP
1K
R238
1-216-206-00 RES-CHIP
2.2K
R239
1-216-206-00 RES-CHIP
2.2K
R241
1-216-827-11 METAL CHIP
3.3K
R242
1-216-073-91 RES-CHIP
10K
R243
1-216-049-11 RES-CHIP
1K
R244
1-216-057-00 RES-CHIP
2.2K
R246
1-216-214-00 RES-CHIP
4.7K
SHORT CHIP
CARBON
CARBON
RES-CHIP
R248
1-216-214-00 RES-CHIP
4.7K
R249
1-216-214-00 RES-CHIP
4.7K
R250
1-216-214-00 RES-CHIP
4.7K
R252
1-216-833-11 METAL CHIP
10K
66
Ref. No.
Part No.
Description
Remark
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
R253
1-216-833-11 METAL CHIP
10K
5%
1/10W
(EXCEPT AEP, UK)
R257
1-216-841-11 METAL CHIP
47K
5%
1/10W
5%
1/10W
0.5% 1/10W
(EXCEPT AEP, UK)
0.5% 1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
R258
1-216-841-11 METAL CHIP
47K
R259
1-216-841-11 METAL CHIP
47K
R260
1-216-841-11 METAL CHIP
47K
R261
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
1/10W
(AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
0.5% 1/10W
(AEP, UK)
R262
1-216-829-11 METAL CHIP
4.7K
R263
1-216-829-11 METAL CHIP
4.7K
R264
1-216-829-11 METAL CHIP
4.7K
R280
R281
1-216-073-00 RES-CHIP
1-216-825-11 METAL CHIP
10K
2.2K
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
0.5% 1/10W
(AEP, UK)
5%
1/10W
5%
1/10W
5%
1/8W
(AEP, UK)
R282
R283
R284
R290
R291
1-216-834-11
1-216-833-11
1-216-829-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
10K
4.7K
47K
2.2K
5%
5%
5%
5%
5%
R292
R293
1-216-833-11 METAL CHIP
1-216-843-11 METAL CHIP
10K
68K
5%
1/8W
(EXCEPT AEP, UK)
R293
1-216-849-11 METAL CHIP
220K
R294
1-216-843-11 METAL CHIP
68K
R294
1-216-849-11 METAL CHIP
220K
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
R295
1-216-837-11 METAL CHIP
22K
5%
R296
R297
R301
R302
1-216-841-11
1-216-841-11
1-216-840-11
1-216-840-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
39K
39K
5%
5%
5%
5%
1/10W
(AEP, UK)
1/10W
1/10W
1/10W
1/10W
R303
R304
R305
R311
R312
1-216-844-11
1-216-844-11
1-216-849-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
82K
82K
220K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R313
R314
R315
R316
R317
1-216-838-11
1-216-797-11
1-216-015-00
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
27K
10
39
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R318
R601
R602
R603
R604
1-216-829-11
1-216-809-11
1-216-809-11
1-216-852-11
1-216-852-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
100
390K
390K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R605
R606
R607
R608
R609
1-216-822-11
1-216-822-11
1-216-845-11
1-216-845-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
1.2K
100K
100K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
5%
5%
5%
5%
1/4W
1/4W
1/8W
5%
1/8W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/8W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
1/10W
1/10W
1/10W
1/10W
1/10W
CX-JN10
MAIN
Ref. No.
Part No.
Description
Remark
R610
R612
R615
R616
R617
1-216-836-11
1-216-829-11
1-216-835-11
1-216-835-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
18K
4.7K
15K
15K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R618
R619
R620
R621
R622
1-216-835-11
1-216-838-11
1-216-838-11
1-216-830-11
1-216-830-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
27K
27K
5.6K
5.6K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R623
R624
R625
1-216-828-11 METAL CHIP
1-216-828-11 METAL CHIP
1-216-827-11 METAL CHIP
3.9K
3.9K
3.3K
R625
1-216-828-11 METAL CHIP
3.9K
R626
1-216-827-11 METAL CHIP
3.3K
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
R626
1-216-828-11 METAL CHIP
3.9K
5%
R627
R628
R629
R630
1-216-825-11
1-216-825-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
10K
10K
5%
5%
5%
5%
1/10W
(AEP, UK)
1/10W
1/10W
1/10W
1/10W
R631
R632
R633
R634
R635
1-216-817-11
1-216-817-11
1-216-827-11
1-216-827-11
1-216-822-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
3.3K
3.3K
1.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R636
R637
R638
R643
R644
1-216-822-11
1-216-815-11
1-216-815-11
1-216-827-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
330
330
3.3K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R645
R651
R652
R653
R654
1-216-829-11
1-216-809-11
1-216-809-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
100
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R655
R656
R657
1-216-837-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-842-11 METAL CHIP
22K
22K
56K
R658
R659
1-216-837-11 METAL CHIP
1-216-825-11 METAL CHIP
22K
2.2K
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
5%
1/10W
R661
R662
R663
R685
R686
1-216-835-11
1-216-841-11
1-216-833-11
1-216-828-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
47K
10K
3.9K
3.9K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R691
R692
R693
R694
R695
1-216-837-11
1-216-833-11
1-216-821-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
1K
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
MOTOR (LD)
Ref. No.
Part No.
MOTOR (TB)
PANEL
Description
Remark
R699
R700
1-216-821-11 METAL CHIP
1-216-837-11 METAL CHIP
1K
22K
5%
5%
1/10W
1/10W
R701
R702
R703
R704
R705
1-216-837-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R730
R731
R732
R733
R734
1-216-833-11
1-216-833-11
1-216-833-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R735
R736
R737
R738
R739
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R801
1-216-813-11 METAL CHIP
220
5%
R807
1-216-821-11 METAL CHIP
1K
5%
1/10W
(AEP, UK)
1/10W
(AEP, UK)
R809
R810
1-216-864-11 SHORT CHIP
1-216-821-11 METAL CHIP
0 (AEP, UK)
1K
5%
R812
1-216-864-11 SHORT CHIP
0 (AEP, UK)
1/10W
(AEP, UK)
< THERMISTOR >
TH101
TH101
TH102
TH102
1-803-790-21
1-804-908-11
1-803-790-21
1-804-908-11
THERMISTOR (EXCEPT AEP, UK)
C-THMS, 55001 (AEP, UK)
THERMISTOR (EXCEPT AEP, UK)
C-THMS, 55001 (AEP, UK)
< WIRE HOLDER >
WH013 1-817-363-11 HOLDER, WIRE 11P (EXCEPT AEP, UK)
WH201 1-816-818-11 HOLDER, WIRE 5P
************************************************************
1-687-133-12 MOTOR (LD) BOARD
*****************
************************************************************
R696
R697
R698
1-216-821-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-833-11 METAL CHIP
1K
22K
10K
5%
5%
5%
1/10W
1/10W
1/10W
1-687-134-12 MOTOR (TB) BOARD
*****************
< CONNECTOR >
CN742 1-784-727-11 CONNECTOR, FFC 5P
************************************************************
A-1055-453-A
A-4752-866-A
A-4752-867-A
A-4752-872-A
PANEL BOARD, COMPLETE (EA)
PANEL BOARD, COMPLETE (AEP, UK)
PANEL BOARD, COMPLETE (E, SP, TW, AUS)
PANEL BOARD, COMPLETE (E51)
**********************
< CAPACITOR >
C213
C214
C215
C216
1-164-156-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
100PF
100PF
5%
5%
5%
25V
50V
50V
50V
67
CX-JN10
PANEL
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
C413
1-126-960-11 ELECT
1uF
20%
50V
(EXCEPT AEP, UK)
D508
D509
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77
C414
1-164-156-11 CERAMIC CHIP
0.1uF
C415
1-164-156-11 CERAMIC CHIP
0.1uF
C501
C502
C503
1-126-960-11 ELECT
1-162-970-11 CERAMIC CHIP
1-126-960-11 ELECT
1uF
0.01uF
1uF
25V
(EXCEPT AEP, UK)
25V
(EXCEPT AEP, UK)
20%
50V
10%
25V
20%
50V
D601
D602
D607
D608
D609
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77 (E51)
1SS133T-77 (EXCEPT AEP, UK)
1SS133T-77 (AEP, UK)
C504
C507
C508
C509
C510
1-126-916-11
1-164-227-11
1-164-156-11
1-126-965-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1000uF
0.022uF
0.1uF
22uF
0.1uF
20%
10%
D611
D612
D614
D620
D621
8-719-991-33
8-719-991-33
8-719-991-33
6-500-334-01
6-500-334-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77 (AEP, UK, EA)
1SS133T-77 (E51)
1SS133T-77 (AEP, UK)
MC2836
MC2836
C601
C809
C902
C903
C904
1-126-947-11
1-126-947-11
1-162-927-11
1-162-927-11
1-162-927-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
100PF
100PF
100PF
20%
20%
5%
5%
5%
35V
35V
50V
50V
50V
D622
D623
D624
D625
D626
6-500-334-01
6-500-334-01
6-500-334-01
6-500-334-01
6-500-334-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2836
MC2836
MC2836
MC2836
MC2836
D627
6-500-334-01 DIODE MC2836
C905
C906
C907
C908
C909
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
FL902
C910
C911
C912
C914
C915
1-162-927-11
1-162-927-11
1-162-927-11
1-126-947-11
1-131-992-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100PF
100PF
100PF
47uF
100000PF
5%
5%
5%
20%
50V
50V
50V
35V
35V
IC201
IC501
IC502
IC801
IC901
6-704-046-01
6-704-135-01
8-759-533-04
6-600-213-01
6-804-211-01
C916
C917
C918
C919
C920
1-126-963-11
1-126-963-11
1-164-156-11
1-162-918-11
1-162-919-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
0.1uF
18PF
22PF
20%
20%
IC901
6-804-212-01 IC LC876756C-52N7-E (EXCEPT AEP, UK)
5%
5%
50V
50V
25V
50V
50V
C921
C922
C923
C924
C926
1-164-156-11
1-162-919-11
1-162-919-11
1-216-864-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
SHORT CHIP
CERAMIC CHIP
0.1uF
22PF
22PF
0
0.1uF
5%
5%
25V
50V
50V
C927
C933
C935
1-164-156-11 CERAMIC CHIP
1-164-173-11 CERAMIC CHIP
1-128-057-11 ELECT
20%
0.1uF
0.0039uF 10%
330uF
20%
6.3V
25V
25V
50V
25V
25V
25V
50V
6.3V
< CONNECTOR >
CN101
CN403
CN601
CN701
1-793-767-11
1-784-784-11
1-784-774-11
1-568-830-11
CONNECTOR, BOARD TO BOARD 30P
CONNECTOR, FFC 23P
CONNECTOR, FFC 13P
CONNECTOR, FFC 11P
< DIODE >
D101
D402
D501
D503
D504
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77 (EXCEPT AEP, UK)
1SS133T-77
1SS133T-77
1SS133T-77
D505
D506
D507
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77
8-719-921-80 DIODE MTZJ-11B
< FLUORESCENT INDICATOR TUBE >
1-518-895-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC
IC
IC
IC
IC
BU2099FV
MM1614A
M62703ML-E1
GP1UE271XK
LC876772B-52N2-E (AEP, UK)
< SHORT >
JR101
JR102
JR204
JR205
JR213
1-216-296-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0 (AEP, UK)
0
0
0
0
JR218
JR219
JR220
JR401
JR402
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR601
JR602
JR703
JR903
JR905
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0 (AEP, UK)
0
0
JR909
JR910
JR911
JR912
JR913
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR914
1-216-296-11 SHORT CHIP
0
< RESISTOR >
68
JW987
JW995
1-247-807-31 CARBON
1-247-807-31 CARBON
100
100
5%
5%
1/4W
1/4W
CX-JN10
PANEL
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R419
1-216-821-11 METAL CHIP
1K
R501
R502
1-249-408-11 CARBON
1-216-841-11 METAL CHIP
180
47K
5%
1/10W
(EXCEPT AEP, UK)
5%
1/4W
5%
1/10W
R503
R504
R505
R506
R507
1-216-841-11
1-249-429-11
1-216-829-11
1-216-815-11
1-216-833-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
4.7K
330
10K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R601
R607
R608
R609
R610
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R611
R612
R625
R626
R627
1-216-821-11
1-216-821-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R628
R629
R630
R631
R637
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R638
R639
R640
R641
R642
1-247-831-11
1-247-831-11
1-247-831-11
1-247-831-11
1-247-831-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R643
R644
R645
R701
R702
1-247-831-11
1-249-421-11
1-249-421-11
1-216-809-11
1-247-807-31
CARBON
CARBON
CARBON
METAL CHIP
CARBON
1K
2.2K
2.2K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/10W
1/4W
R703
R704
R705
R706
R707
1-216-809-11
1-414-760-21
1-414-760-21
1-216-809-11
1-216-809-11
METAL CHIP
100
5%
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
METAL CHIP
100
5%
METAL CHIP
100
5%
1/10W
R708
R709
R817
R818
R902
1-414-760-21
1-247-807-31
1-249-401-11
1-247-873-11
1-216-841-11
FERRITE, EMI (SMD) (1608)
CARBON
100
CARBON
47
CARBON
56K
METAL CHIP
47K
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/10W
R903
R904
R905
R906
R907
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R908
R909
R910
R911
R912
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R913
R914
R915
R916
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< TRANSISTOR >
Q601
Q602
Q603
Q604
Q605
8-729-116-57
8-729-140-04
8-729-140-04
8-729-900-80
8-729-900-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1068-K
2SB1116A-L
2SB1116A-L
DTC114ES
DTC114ES
Q606
Q607
Q901
Q902
Q903
8-729-900-80
8-729-027-23
8-729-120-28
8-729-027-31
8-729-027-59
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114ES
DTA114EKA-T146
2SC1623-L5L6
DTA124EKA-T146
DTC144EKA-T146
< RESISTOR/FERRITE BEAD >
R101
1-247-863-11 CARBON
22K
5%
1/4W
(AEP, UK)
1/4W
(AEP, UK)
1/4W
(AEP, UK)
1/4W
1/4W
R102
1-249-436-11 CARBON
39K
5%
R103
1-249-436-11 CARBON
39K
5%
R104
R105
1-247-831-11 CARBON
1-247-831-11 CARBON
1K
1K
5%
5%
R106
R107
R108
R109
R110
1-247-831-11
1-247-831-11
1-247-831-11
1-247-831-11
1-247-831-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R111
R112
R113
R114
R118
1-247-831-11
1-247-831-11
1-247-831-11
1-247-831-11
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R119
R121
R122
R225
R226
1-247-831-11
1-247-831-11
1-247-831-11
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R227
R228
R247
R248
R249
1-249-429-11
1-249-429-11
1-216-834-11
1-216-845-11
1-216-838-11
CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
12K
100K
27K
5%
5%
5%
5%
5%
1/4W
1/4W
1/10W
1/10W
1/10W
R254
R261
R262
R263
R264
1-216-849-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
10K
10K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R334
R335
R336
R415
1-216-833-11
1-216-833-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
100
R416
1-216-850-11 METAL CHIP
270K
R417
1-216-835-11 METAL CHIP
15K
R418
1-216-853-11 METAL CHIP
470K
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
5%
1/10W
(EXCEPT AEP, UK)
1/10W
1/10W
69
CX-JN10
PANEL
Ref. No.
PT
Part No.
SENSOR
Description
Remark
Ref. No.
Part No.
Description
Remark
R917
1-216-845-11 METAL CHIP
100K
5%
1/10W
R973
1-216-845-11 METAL CHIP
100K
R918
R919
R920
R921
R922
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R974
1-247-879-11 CARBON
100K
R975
R976
1-247-879-11 CARBON
1-216-825-11 METAL CHIP
100K
2.2K
R923
R924
R925
R926
R927
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R928
R929
R930
R931
R932
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R933
R934
R935
R936
R937
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R938
R939
R940
R941
R942
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-249-420-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
100K
100K
100K
100K
1.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
R943
R944
R945
R946
R947
1-249-420-11
1-249-427-11
1-249-427-11
1-216-845-11
1-216-845-11
CARBON
CARBON
CARBON
METAL CHIP
METAL CHIP
1.8K
6.8K
6.8K
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/10W
1/10W
R948
R949
R950
R953
R954
1-216-845-11
1-216-845-11
1-216-845-11
1-247-879-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
100K
100K
100K
100K
3.9K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
R957
R958
R959
R960
R961
1-247-879-11
1-219-570-11
1-216-853-11
1-216-809-11
1-216-821-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10M
470K
100
1K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R962
R963
R964
R965
R966
1-216-821-11
1-216-821-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R967
R968
R969
R970
R971
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-247-879-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
R972
1-249-439-11 CARBON
68K
5%
R972
1-247-879-11 CARBON
100K
R973
1-216-843-11 METAL CHIP
68K
5%
1/10W
(EXCEPT AEP, UK)
5%
1/4W
5%
5%
1/4W
1/10W
< VIBRATOR >
X901
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
X902
1-795-880-11 VIBRATOR, CERAMIC (8.64MHz)
************************************************************
1-688-399-15 PT BOARD (AEP, UK, AUS)
1-688-763-12 PT BOARD (E, EA, E51, SP, TW)
*********
< CAPACITOR >
C003
1-162-974-11 CERAMIC CHIP
0.01uF
C091
1-165-621-11 CERAMIC CHIP
0.1uF
50V
(E, EA, E51, SP, TW)
50V
(AEP, UK)
< CONNECTOR >
* CN090
* CN091
CN093
< DIODE >
D002
D003
D091
D092
70
6-500-334-01
6-500-335-01
6-500-334-01
6-500-335-01
DIODE
DIODE
DIODE
DIODE
MC2836 (E, EA, E51, SP, TW)
MC2838 (E, EA, E51, SP, TW)
MC2836 (AEP, UK, AUS)
MC2838 (AEP, UK, AUS)
< TRANSFORMER >
0 PT002
0 PT002
0 PT011
0 PT011
1-439-976-11
1-439-977-11
1-439-735-11
1-439-976-11
TRANSFORMER, POWER (E, E51, SP, TW)
TRANSFORMER, POWER (EA)
TRANSFORMER, POWER (AEP, UK)
TRANSFORMER, POWER (AUS)
< RELAY >
0 RY001
1/4W
(AEP, UK)
5%
1/4W
(EXCEPT AEP, UK)
5%
1/10W
(AEP, UK)
1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
(E, EA, E51, SP, TW)
1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
(AEP, UK, AUS)
1-817-542-11 CONNECTOR 11P (E, EA, E51, SP, TW)
1-755-276-11 RELAY, POWER
< SWITCH >
0 S001
1-786-404-11 SELECTOR, VOLTAGE (SWS-2201)
(VOLTAGE SELECTOR) (E, EA, E51, SP)
< WIRE HOLDER >
WH091 1-817-362-11 HOLDER, WIRE 7P (AEP, UK)
WH093 1-817-363-11 HOLDER, WIRE 11P (AUS)
************************************************************
1-687-132-12 SENSOR BOARD
*************
< CONNECTOR >
CN731
1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-JN10
SENSOR
Ref. No.
Part No.
Description
Remark
Ref. No.
< IC >
Part No.
Description
SW
Remark
ACCESSORIES
************
IC731
(NOT SUPPLIED)
************************************************************
1-687-669-12 SW BOARD
*********
0
0
0
1-569-007-12 ADAPTOR, CONVERSION 2P (E)
1-569-008-32 ADAPTOR, CONVERSION (E51, EA, SP)
1-770-019-51 ADAPTOR, CONVERSION PLUG (UK)
< SWITCH >
S751
1-786-514-11 SWITCH, LEVER (SLIDE)
(OPEN/CLOSE DETECT)
************************************************************
MISCELLANEOUS
**************
55
106
107
108
110
1-796-485-51
1-751-688-11
1-769-944-11
1-769-857-11
1-773-182-11
254
254
256
1-693-615-11 TUNER (FM/AM) (EXCEPT AEP, UK)
1-693-616-11 TUNER (FM/AM) (AEP, UK)
1-769-943-11 WIRE (FLAT TYPE) (11 CORE)
(EXCEPT AEP, UK)
1-773-007-11 WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
1-827-222-11 WIRE (FLAT TYPE) (19 CORE)
256
257
DECK, MECHANICAL (CWM43FF13)
WIRE (FLAT TYPE) (13 CORE)
WIRE (FLAT TYPE) (11 CORE)
WIRE (FLAT TYPE) (5 CORE)
WIRE (FLAT TYPE) (23 CORE)
0 259
0 259
0 259
0 259
0 259
1-696-571-11
1-757-140-11
1-775-787-62
1-775-790-42
1-827-226-21
CORD, POWER (EA)
CORD, POWER (AEP, E51, SP)
CORD, POWER (UK)
CORD, POWER (AUS)
CORD, POWER (E)
0 259
260
509
602
0 652
1-827-597-11
1-400-285-11
1-776-182-11
1-471-035-11
A-4735-357-A
CORD, POWER (TW)
F-BEAD, E2515MRT
WIRE (FLAT TYPE) (5 CORE)
MAGNET ASSY
BASE ASSY, OP (KSM-213DCP)
(including M701 (SLED), M702 (SPINDLE))
653
C911
1-823-859-11 WIRE (FLAT TYPE) (16 CORE)
1-162-282-31 CERAMIC
100PF
10%
C912
1-162-282-31 CERAMIC
100PF
10%
C913
1-128-821-11 CERAMIC
1000PF
5%
C950
1-128-815-11 CERAMIC
330PF
5%
C951
1-127-888-11 CERAMIC
0.1uF
10%
C952
1-127-888-11 CERAMIC
0.1uF
10%
M741
M751
0 PT002
A-4723-963-A MOTOR ASSY, TABLE
A-4736-655-A MOTOR ASSY, LOADING
1-439-845-11 TRANSFORMER, POWER (AEP, UK)
0 PT002
0 PT004
0 PT004
S711
1-443-050-11
1-439-928-11
1-439-931-11
1-477-680-12
50V
(AEP, UK)
50V
(AEP, UK)
50V
(AEP, UK)
50V
50V
(AEP, UK)
50V
(AEP, UK)
TRANSFORMER, POWER (AUS)
TRANSFORMER, POWER (E, E51, SP, TW)
TRANSFORMER, POWER (EA)
ENCODER, ROTARY
(DISC TRAY ADDRESS DETECT)
************************************************************
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
71
CX-JN10
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
Date
2004.03
Description of Revision
New