Download Samsung DVD-V4800 Service manual

DVD-VCR COMBINATION
Chassis : Kaiser
DVD-V4300
DVD-V4600
SERVICE MANUAL
SERVICE
Manual
DVD-V4300/V4600
If you want to know additional information which is not included on this Service Manual, please refer to the
DVD-V4600 Training Manual (AK82-00460A).
DVD-VCR COMBINATION
CONTENTS
1. Precautions
ELECTRONICS
2. Alignment and Adjustment
3. Exploded Views and Parts List
4. Electrical Parts List
5. Block Diagram
6. Schematic Diagrams
DVD-V4300
DVD-V4600
This Service Manual is a property of Samsung Electronics Co .,Ltd.
Any unauthorized use of Manual can be punished under applicable
International and/or domestic law.
© Samsung Electronics Co., Ltd. FEB. 2003
Printed in Korea
AK82-00516A
IMPORTANT SERVICE GUIDE
◆ MODE SWITCH (PROGRAM SWITCH) ASSEMBLY POINT
1) When installing the ass’y deck on the Main PCB, be sure to align the assembly point of mode switch.
ASSEMBLY POINT
VCR MAIN PCB
Fig. 1
◆ HOW TO EJECT THE CASSETTE TAPE
(If the tape is stuck in the unit)
1) Turn the Gear Worm Πclockwise in the direction of arrow with a screwdriver. (See Fig. 2)
(Other method ; Remove the screw of Motor Load Ass’y, Separate the Motor Load Ass’y)
2) When Slider S, T approachs the unloading position, rotate holder Clutch counterclockwise after inserting screwdriver in the
frame’s bottom hole in order to wind the unwound tape. (Refer to Fig. 3)
(If you rotate Gear Worm Πcontinuously when tape is unwinding, you may cause tape contamination by grease and
tape damage. Be sure to wind the unwound tape with the unit in the horizontall position.)
3) Rotate Gear Worm Πclockwise using a screwdriver until the mecha is in the eject state. Remove the tape. (Refer to Fig. 2)
FRAME
ΠGEAR WORM
Fig. 2
Fig. 3
1. Precautions
1-1 Safety Precautions
1) Before returning an instrument to the customer,
always make a safety check of the entire instrument,
including, but not limited to, the following items:
(1) Be sure that no built-in protective devices are
defective or have been defeated during servicing.
(1)Protective shields are provided to protect both
the technician and the customer. Correctly replace
all missing protective shields, including any
removed for servicing convenience.
(2)When reinstalling the chassis and/or other assembly in the cabinet, be sure to put back in place
all protective devices, including, but not limited to,
nonmetallic control knobs, insulating fish papers,
adjustment and compartment covers/shields, and
isolation resistor/capacitor networks. Do not operate this instrument or permit it to be operated without all protective devices correctly installed and
functioning.
(2) Be sure that there are no cabinet openings through
which adults or children might be able to insert
their fingers and contact a hazardous voltage. Such
openings include, but are not limited to, excessively wide cabinet ventilation slots, and an improperly fitted and/or incorrectly secured cabinet back
cover.
(3) Leakage Current Hot Check-With the instrument
completely reassembled, plug the AC line cord
directly into a 120V AC outlet. (Do not use an isolation transformer during this test.) Use a leakage
current tester or a metering system that complies
with American National Standards institute (ANSI)
C101.1 Leakage Current for Appliances and
Underwriters Laboratories (UL) 1270 (40.7). With
the instrument’s AC switch first in the ON position
and then in the OFF position, measure from a
known earth ground (metal water pipe, conduit,
etc.) to all exposed metal parts of the instrument
(antennas, handle brackets, metal cabinets, screwheads, metallic overlays, control shafts, etc.), especially any exposed metal parts that offer an electrical return path to the chassis.
Any current measured must not exceed 0.5mA.
Reverse the instrument power cord plug in the outlet and repeat the test. See Fig. 1-1.
Any measurements not within the limits specified
herein indicate a potential shock hazard that must
be eliminated before returning the instrument to
the customer.
(READING SHOULD
NOT BE ABOVE
0.5mA)
LEAKAGE
CURRENT
TESTER
DEVICE
UNDER
TEST
TEST ALL
EXPOSED METER
SURFACES
2-WIRE CORD
ALSO TEST WITH
PLUG REVERSED
(USING AC ADAPTER
PLUG AS REQUIRED)
EARTH
GROUND
Fig. 1-1 AC Leakage Test
(4) Insulation Resistance Test Cold Check-(1) Unplug
the power supply cord and connect a jumper wire
between the two prongs of the plug. (2) Turn on the
power switch of the instrument. (3) Measure the
resistance with an ohmmeter between the
jumpered AC plug and all exposed metallic cabinet
parts on the instrument, such as screwheads,
antenna, control shafts, handle brackets, etc. When
an exposed metallic part has a return path to the
chassis, the reading should be between 1 and 5.2
megohm. When there is no return path to the chassis, the reading must be infinite. If the reading is
not within the limits specified, there is the possibility of a shock hazard, and the instrument must be
repaired and rechecked before it is returned to the
customer. See Fig. 1-2.
Antenna
Terminal
Exposed
Metal Part
ohm
ohmmeter
Fig. 1-2 Insulation Resistance Test
Samsung Electronics
1-1
Precautions
2) Read and comply with all caution and safety related notes on or inside the cabinet, or on the chassis.
3) Design Alteration Warning-Do not alter or add to
the mechanical or electrical design of this instrument. Design alterations and additions, including
but not limited to, circuit modifications and the
addition of items such as auxiliary audio output
connections, might alter the safety characteristics of
this instrument and create a hazard to the user. Any
design alterations or additions will make you, the
servicer, responsible for personal injury or property
damage resulting therefrom.
4) Observe original lead dress. Take extra care to
assure correct lead dress in the following areas:
(1) near sharp edges, (2) near thermally hot parts (be
sure that leads and components do not touch thermally hot parts), (3) the AC supply, (4) high voltage,
and (5) antenna wiring. Always inspect in all areas
for pinched, out-of-place, or frayed wiring, Do not
change spacing between a component and the
printed-circuit board. Check the AC power cord for
damage.
1-2
5) Components, parts, and/or wiring that appear to
have overheated or that are otherwise damaged
should be replaced with components, parts and/ or
wiring that meet original specifications.
Additionally, determine the cause of overheating
and/or damage and, if necessary, take corrective
action to remove any potential safety hazard.
6) Product Safety Notice-Some electrical and mechanical parts have special safety-related characteristics
which are often not evident from visual inspection,
nor can the protection they give necessarily be
obtained by replacing them with components rated
for higher voltage, wattage, etc. Parts that have special safety characteristics are identified by shading,
an (
)or a (
)on schematics and parts lists. Use
of a substitute replacement that does not have the
same safety characteristics as the recommended
replacement part might create shock, fire and/or
other hazards. Product safety is under review continuously and new instructions are issued whenever appropriate.
Samsung Electronics
Precautions
1-2 Servicing Precautions
CAUTION : Before servicing units covered by this
service manual and its supplements, read and follow
the Safety Precautions section of this manual.
Note : If unforseen circumstances create conflict
between the following servicing precautions and any
of the safety precautions, always follow the safety precautions. Remember: Safety First.
1-2-1 General Servicing Precautions
(1) a. Always unplug the instrument’s AC power cord
from the AC power source before (1) re-moving
or reinstalling any component, circuit board,
module or any other instrument assembly, (2)
disconnecting any instrument electrical plug or
other electrical connection, (3) connecting a test
substitute in parallel with an electrolytic capacitor in the instrument.
b. Do not defeat any plug/socket B+ voltage interlocks with which instruments covered by this
service manual might be equipped.
c. Do not apply AC power to this instrument and
/or any of its electrical assemblies unless all
solid-state device heat sinks are correctly installed.
d. Always connect a test instrument’s ground lead
to the instrument chassis ground before connecting the test instrument positive lead. Always
remove the test instrument ground lead last.
(4) An insulation tube or tape is sometimes used and
some components are raised above the printed
wiring board for safety. The internal wiring is
sometimes clamped to prevent contact with heating components. Install such elements as they
were.
(5) After servicing, always check that the removed
screws, components, and wiring have been installed correctly and that the portion around the
serviced part has not been damaged and so on.
Further, check the insulation between the blades of
the attachment plug and accessible conductive
parts.
1-2-2 Insulation Checking Procedure
Disconnect the attachment plug from the AC outlet
and turn the power ON. Connect the insulation resistance meter (500V) to the blades of the attachment
plug. The insulation resistance between each blade of
the attachment plug and accessible conductive
parts(see note) should be more than 1 Megohm.
Note : Accessible conductive parts include metal panels, input terminals, earphone jacks, etc.
Note : Refer to the Safety Precautions section ground
lead last.
(2) The service precautions are indicated or printed on
the cabinet, chassis or components. When servicing, follow the printed or indicated service precautions and service materials.
(3) The components used in the unit have a specified
flame resistance and dielectric strength.
When replacing components, use components
which have the same ratings. Components identified by shading, by( ) or by ( ) in the circuit diagram are important for safety or for the characteristics of the unit. Always replace them with the exact
replacement components.
Samsung Electronics
1-3
Precautions
1-3 ESD Precautions
Electrostatically Sensitive Devices (ESD)
Some semiconductor (solid state) devices can be damaged easily by static electricity.
Such components commonly are called Electrostatically Sensitive Devices(ESD). Examples of typical ESD
devices are integrated circuits and some field-effect
transistors and semiconductor chip components. The
following techniques should be used to help reduce
the incidence of component damage caused by static
electricity.
(1) Immediately before handling any semiconductor
component or semiconductor-equipped assembly,
drain off any electrostatic charge on your body by
touching a known earth ground. Alternatively,
obtain and wear a commercially available discharging wrist strap device, which should be
removed for potential shock reasons prior to applying power to the unit under test.
(7) Immediately before removing the protective materials from the leads of a replacement ESD device,
touch the protective material to the chassis or circuit assembly into which the device will be
installed.
CAUTION : Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.
(8) Minimize bodily motions when handling unpackaged replacement ESD devices. (Otherwise harmless motion such as the brushing together of your
clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity sufficient
to damage an ESD device).
(2) After removing an electrical assembly equipped
with ESD devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge buildup or exposure of the assembly.
(3) Use only a grounded-tip soldering iron to solder or
unsolder ESD devices.
(4) Use only an anti-static solder removal devices.
Some solder removal devices not classified as
“anti-static” can generate electrical charges sufficient to damage ESD devices.
(5) Do not use freon-propelled chemicals. These can
generate electrical charges sufficient to damage
ESD devices.
(6) Do not remove a replacement ESD device from its
protective package until immediately before your
are ready to install it.(Most replacement ESD
devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or
comparable conductive materials).
1-4
Samsung Electronics
Precautions
1-4 Handling the optical pick-up
The laser diode in the optical pick up may suffer electrostatic breakdown because of potential static electricity from clothing and your body.
WRIST-STRAP
FOR GROUNDING
1M
The following method is recommended.
(1) Place a conductive sheet on the work bench (The
black sheet used for wrapping repair parts.)
(2) Place the set on the conductive sheet so that the
chassis is grounded to the sheet.
(3) Place your hands on the conductive sheet(This
gives them the same ground as the sheet.)
(4) Remove the optical pick up block
(5) Perform work on top of the conductive sheet. Be
careful not to let your clothes or any other static
sources to touch the unit.
THE UNIT
1M
CONDUCTIVE SHEET
Fig.1-3
(6) Short the short terminal on the PCB, which is inside the Pick-Up ASS’Y, before replacing the PickUp. (The short terminal is shorted when the PickUp Ass’y is being lifted or moved.)
(7) After replacing the Pick-up, open the short terminal on the PCB.
◆ Be sure to put on a wrist strap grounded to the
sheet.
◆ Be sure to lay a conductive sheet made of copper
etc. Which is grounded to the table.
Samsung Electronics
1-5
Precautions
1-5 Pick-up disassembly and reassembly
1-5-1 Disassembly
1-5-2 Assembly
1) Remove the power cord.
2) Disassemble the Deck-Assy.
3) Make solder land 2 points short on Pick-up.
(See Fig. 1-4)
4) Disassemble the Pick-up.
1) Replace the Pick-up.
2) Remove the soldering 2 points on Pick-up.
3) Reassemble the Deck-Assy.
Note : If the assembly and disassembly are not done in correct sequence, the Pick-up may be damaged.
SOLDER LAND 2 POINTS SHORT
PICK-UP ASS'Y
Fig. 1-4
1-6
Samsung Electronics
2. Alignment and Adjustments
2-1 VCR Adjustment
2-1-1 Reference
1) X-Point (Tracking center) adjustment, “Head switching adjustment” and “NVRAM option setting” can be adjusted with remote control.
2) When replacing the Main PCB Micom (IC601) and NVRAM (IC603 ; EEPROM) be sure to adjust the “Head switching adjustment” and
“NVRAM option setting”.
3) When replacing the cylinder ass’y, be sure to adjust the “X-Point” and “Head switching adjustment”.
4) How to adjust.
- Intermittently short-circuit the Test Point on Main PCB with pincers to the adjustment mode.
- If the corresponding adjustment button is pressed, the adjustment is performed automatically.
- When the adjustment is completed, be sure to turn the power off.
2-1-1(a) Location of adjustment button of remote control
X-Point (Tracking Center) Adjustment ;
NVRAM Option Setting ;
Head Switching Adjustment ;
Fig. 2-1
Samsung Electronics
2-1
Alignment and Adjustments
2-1-1(b) TEST location for adjustment mode setting
Short-Circuit for few seconds and release.
(Just one time)
Fig. 2-2 VCR Main PCB (Top View)
2-2
Samsung Electronics
Alignment and Adjustments
2-1-2 Head Switching Point Adjustment
1) Playback the alignment tape.
2) Intermittently short-circuit the two Test Points on VCR Main PCB while setting the adjustment mode. (See Fig.
2-2)
3) Press the “1, 0” buttons; remote control adjustment operates automatically. (See Fig. 2-1)
2-1-3 NVRAM Option Setting
1) NVRAM Option is adjusted in the factory.
2) In case Main PCB Micom (IC601) and NVRAM (IC603 ; EEPROM) are replaced, be sure to set the corresponding option number of the
required model. (If the option is not set, the unit will not operate.)
1) Intermittently short-circuit the two Test Points on VCR Main PCB. (See Fig. 2-2)
2) Press the “1, 4” button on the remote control. The option setting appears. (See Fig. 2-3)
3) Select the option number (See table 2-1) of corresponding model with “ , , , ” buttons on the
remote control.
4) After selecting the option number is completed, press the “ ” button of remote control.
(If “ ” button is pressed, the selected number is changescolor. ; See Fig. 2-4)
5) Press the “ENTER” button of remote control again to store the option number.
6) Turn the Power off.
01 02 03 04 05 06 07 08
01 02 03 04 05 06 07 08
09 10 11 12 13 14 15 16
09 10 11 12 13 14 15 16
17 18 19 20 21 22 23 24
17 18 19 20 21 22 23 24
25 26 27 28 29 30 31 32
25 26 27 28 29 30 31 32
33 34 35 36 37 38 39 40
33 34 35 36 37 38 39 40
MOVE :
SAVE :
ENTER
Fig. 2-3
MOVE :
COMPLETE
Fig. 2-4
<Table 2-1 NVRAM Option Table>
MODEL
DVD-V4300
DVD-V4600
Samsung Electronics
OPTION NUMBERS
2, 7, 8, 9, 14, 16, 18, 22, 25, 28
2, 7, 8, 9, 14, 16, 18, 22, 25, 28
2-3
Alignment and Adjustments
2-2 DVD Adjustment
2-2-1 Location of Test Point
S
Fig. 2-5 Location of test Point (Main PCB - Top Side)
2-4
Samsung Electronics
Alignment and Adjustments
2-2-2 Skew Adjustment
2-2-2(a) Adjustment Spec. and Test Point
◆ Test Disc ; Service not Available
<Table 2-2>
Test Disc
Adjustment Spec.
Test Point
Adjustment Location
TDV-533
Chapter 14
Flat Waveform
“ENV”
(DVD Main PCB - Top Side)
(See Fig. 2-5)
Ass’y Deck - Top Side
(See Fig. 2-6)
Fig. 2-6 Ass’y Deck (Top Side)
Samsung Electronics
2-5
Alignment and Adjustments
2-2-2(b) SKEW Adjustment Method
Needed to minimize the variations in Skew of the Pickup unit and to provide optimum match with the recorded
signal on the Disc.
1) Connect an Oscilloscope to the “ENV” Test Point (See Fig. 2-5).
2) Connect Power, Open the Tray and Play Ch.14 Which is in the TDV-533 Disc.
◆ Set the Oscilloscope Range as follows :
(Voltage ; 50mV/Div., Frequency ; 10m Sec.)
3) Adjust the Screws “A” and “B” (See Fig. 2-6) using a Hex screwdriver until you obtain a Flat Waveform and
the picture is stable.
Then, go to Chapter 1 and make sure the Waveform is Flat here as well.
If not, you have to go back to Chapter 14 and adjust again.
If you cannot obtain a Flat waveform, then the unit is defective.
Note : The Deck must be in a horizontal position. Use both “A” and “B” screws to adjust.
Typical Waveform before Adjustment
Waveform after Correct Adjustment
Fig. 2-7 Envelope Waveform
2-6
Samsung Electronics
Alignment and Adjustments
2-3 VCR Mechanical Adjustment
2-3-1 Tape Transport System and Adjustment Locations
The tape transport system has been adjusted precisely in the factory. Alignment is not necessary except for the
following :
1) Noise observed on the screen.
2) Tape damage.
3) Parts replacement in the tape transport system.
Lower flange height of tape guide is used as the reference for the transport adjustment.
To maintain the height of the tape guide and prevent damage, do not apply excessive force onto the main base.
CYLINDER ASS'Y
GUIDE ROLLER "S"
GUIDE ROLLER "T"
FULL ERASE HEAD
HEIGHT SCREW
#3 GUIDE POST
TENSION POST
PINCH ROLLER
TILT SCREW
X - POSITION
ADJUST SILT
#9 GUIDE POST
AZIMUTH SCREW
CAPSTAN
#8 GUIDE POST
TAKE UP REEL DISK
SUPPLY REEL DISK
Fig. 2-8 Location of Tape Transport Adjustment
PINCH ROLLER
FE HEAD
CYLINDER ASS'Y
GUIDE ROLLER "S"
GUIDE ROLLER "T"
POST TENSION
#8 GUIDE POST #9 GUIDE POST
#3 GUIDE POST
MAIN BASE
ACE HEAD
CAPSTAN SHAFT
Fig. 2-9 Tape Travel Diagram
Samsung Electronics
2-7
Alignment and Adjustments
2-3-2 Tape Transport System Adjustment
When parts are replaced, perform the required adjustments by referring to procedures for the tape transport
system. If there are any changes to the tape path, first run a T-120 tape and make sure excessive tape wrinkle does
not occur at the tape guides.
◆ If tape wrinkle is observed at the guide roller S, T, turn the guide roller S, T until wrinkle disappears.
◆ If the tape wrinkle is still observed at the tape guide, perform the tilt adjustment of the ACE head.
(1) ACE Head Assembly Adjustment
a. ACE HEAD HEIGHT ADJUSTMENT
1) Run the alignment tape (Color bar) in the playback mode.
2) Observe surface of the audio head using a dental mirror.
3) Turn screw (C) clockwise or counterclockwise until the gap of lower tape edge and the lower edge of the
control head is about 0.25mm. (Refer to Fig. 2-10 and 2-11)
SCREW (A)
TLIT ADJUST
SCREW (C)
HEIGHT ADJUST
X-POSITION
ADJUSTING SLIT
SCREW (D)
X-POSITION LOCKING
SCREW (B)
AZIMUTH ADJUST
Fig. 2-10 Location of ACE Head Adjustment Screw
AUDIO HEAD
VIDEO HEAD
0 ~ 0 .25 mm
CONTROL HEAD
Fig. 2-11 ACE Head Height Adjustment
2-8
Samsung Electronics
Alignment and Adjustments
b. ACE HEAD TILT ADJUSTMENT
1) Playback a blank tape and observe the position of the tape at the lower flange of tape guide.
2) Confirm that there is no curl or wrinkle at the lower flange of tape guide as shown in Fig. 2-12 (B).
3) If a curl or wrinkle of the tape occurs, slightly turn the screw (A) tilt adjust on the ACE head ass’y.
4) Reconfirm the ACE head height.
(A)
(B)
(BAD)
(GOOD)
WRINKLE
Fig. 2-12 Tape Guide Check
c. AUDIO AZIMUTH ADJUSTMENT
1) Load alignment tape (Mono scope) and playback the 7KHz signal.
2) Connect channel-1 scope probe to audio output.
3) Adjust screw (B) to achieve maximum audio level. (See Fig. 2-10)
Samsung Electronics
2-9
Alignment and Adjustments
d. ACE HEAD POSITION (X-POINT) ADJUSTMENT
1) Playback the alignment tape (Color bar)
2) Intermittently short-circuit the two Test Points on VCR Main PCB. (See Fig. 2-2)
3) Press the “0, 5” remote control buttons, then adjustment is operates automatically. (See Fig. 2-1)
4) Connect the CH-1 probe to “Envelope” the CH-2 probe to “H’D switching pulse” and then trigger to CH-1.
5) Insert the (-) driver into the X-Point adjustment hole and adjust it so that envelope waveform is maximum.
Test point :
TP2 (Audio Output)
TP3 (Envelope)
TP4 (H’D S/W -Trigger)
TP5 (Control Pulse)
CONTROL PULSE
HEAD SWITCHING
ENVELOPE
AUDIO OUTPUT
Fig. 2-13 Location of Test point (VCR Main PCB-Top View)
2-10
Samsung Electronics
Alignment and Adjustments
(2) Linearity adjustment (Guide roller S, T adjustment)
1) Playback the Mono Scope alignment tape (SP mode).
2) Observe the video envelope signal on an oscilloscope (triggered by the video switching pulse).
3) Make sure the video envelope waveform (at its minimum) meets the specification shown in Fig. 2-14.
If it does not, adjust as follows :
Note :
a=Maximum output of the video RF envelope.
b=Minimum output of the video RF envelope at the entrance side.
c=Minimum output of the video RF envelope at the center point.
d=Maximum output of the video RF envelope at the exit side.
4) If the section A in Fig. 2-15 does not meet the specification, adjust the guide roller S up or down.
5) If the section B in Fig. 2-15 does not meet the specification, adjust the guide roller T up or down.
c
a
b
d
abcd
63%
c,b,d/a
Fig. 2-14 Envelope Waveform Adjustment
H'D SWITCHING PULSE
A
ENVELOPE
A
B
B
Fig. 2-15 Adjustment Points
Samsung Electronics
2-11
Alignment and Adjustments
6) Play back the Mono Scope alignment tape (SP mode).
7) Connect an oscilloscope CH-1 to the “Envelope” and CH-2 to the “H’D SW Pulse” for triggering.
8) Turn the guide roller heads with a flat head (
) driver to obtain a flat video RF envelope as shown in Fig. 2-16.
IDEAL ENVELOPE
S HEIGHT TOO HIGH
S HEIGHT TOO LOW
T HEIGHT TOO HIGH
GUIDE ROLLER S
T HEIGHT TOO LOW
GUIDE ROLLER T
Fig. 2-16 Guide Roller S, T Height Adjustment
2-12
Samsung Electronics
Alignment and Adjustments
(3) Check Transitional Operation from RPS to Play
Check transition from RPS mode to play mode : Using a pre-recorded SP tape, make sure the entry side of envelope comes to an appropriate steady state within 3 seconds (as shown in Fig. 2-17).
If the envelope waveform does not reach specified peak-to peak amplitude within 3 seconds, adjust as follows :
1) Make sure there is no gap between the supply roller lower flange and the tape.
If there is a gap, adjust the supply guide roller again.
2) Change operation mode from the RPS to the play mode (again) and make sure the entry side of envelope rises
within 3 seconds.
ENTRANCE SIDE ENVELOPE
Fig. 2-17 Video Envelope Rising when Operation mode Changes from RPS to Play Mode
(4) Envelope Check
1) Make recordings on T-120 (E-120) and T-160 (E-180) tape.
Make sure the playback output envelope meets the specification as shown in Fig. 2-18.
2) Play back a self recorded tape (recording made on the unit using with T-120 (E-120).
The video envelope should meet the specification as shown in Fig. 2-18.
In SP mode, (A) should equal (B).
If the head gap is wide, upper cylinder should be checked.
A
B
Fig. 2-18 Envelope Input and Output Level
(5) Tape Wrinkle Check
1) Run the T-160 (E-180) tape in the playback, FPS, RPS and Pause modes and observe tape wrinkle at
each guide.
2) If excessive tape wrinkle is observed, perform the following adjustments in Playback mode :
◆ Tape wrinkle at the guide roller S, T section : Linearity adjustment.
◆ Tape wrinkle at tape guide flange : ACE head assembly coarse adjustment.
Samsung Electronics
2-13
Alignment and Adjustments
2-3-3 Reel Torque
1) The rotation of the capstan motor causes the holder clutch ass’y to rotate through the belt pulley.
2) The spring wrap PLAY/REV of holder clutch ass’y drives the disk reel S, T through gear idler by rotation of
gear center ass’y.
3) Brake is operated by slider cam at FF/REW mode.
4) Transportation of accurate driving force is done by gears. (Gear Center Ass’y)
Note : If the spec. does not meet the followings specifications, replace the holder clutch ass’y and then recheck.
<Table 2-4>
MODE
TORQUE g/cm
GAUGE
PB
42 ± 11
Cassette Torquemeter
RPS
145 ± 30
Cassette Torquemeter
2-14
Samsung Electronics
3. Exploded View and Parts List
3-1 Cabinet Assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 3-2
3-2 VCR Mechanical Parts (Top Side) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 3-4
3-3 VCR Mechanical Parts (Bottom Side) - - - - - - - - - - - - - - - - - - - - - - - - - - - - 3-6
3-4 DVD Mechanical Parts - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 3-8
Notice
You can search for the updated part code through ITSELF web site.
URL; http://itself.sec.samsung.co.kr
Samsung Electronics
3-1
3-2
VCR DECK (S.N.A.)
DVD DECK (S.N.A.)
157
157
2
153
3
BRACKET-FRAME (S.N.A.)
21
701 (FUNCTION PCB)
LD601A
602 (DVD MAIN PCB)
S602A
22
1
603 (S.M.P.S. PCB)
200
ASSY FRAME (S.N.A)
101
S.N.A. : Service Not Available
601 (VCR MAIN PCB)
TM401B
UT01
155
Exploded View and Parts List
3-1 Cabinet Assembly
Samsung Electronics
Exploded View and Parts List
Loc. No
1
2
3
21
22
101
153
155
157
200
601
602
603
701
LD601A
S602A
TM401B
UT01
Parts No.
AK97-00883B
AK97-00717L
AK64-00628A
AK64-00557A
AK64-00334A
AK64-00627B
AK64-00556H
AC61-62032A
AK64-00535A
AC60-12126A
6003-000275
AC60-10063A
AC39-10014A
AC39-00019A
AK92-00387D
AK92-00341A
AK94-00006B
AK94-00011A
AK94-00010A
AC61-00340A
AC61-00341A
AK97-00749B
AK59-00008A
Samsung Electronics
Description ; Specification
ASSY-PANEL FRONT;ASS,DVD-V4300/XAX,04-C
ASSY-PANEL FRONT;HIPS 94HB,DVD-V4600/XAP
DOOR-TRAY;DVD-V340,ABS,T2,H17.8,W130.8,DOOR-TRAY;DVD-V4500/XAA,ABS 94HB,T2.0,H1
DOOR-SPRING;DVD-V3500,SWPB,,,,-,,
DOOR-CASSETTE;DVD-V4300/XAX,ABS 94,T2.2,
DOOR-CASSETTE;DVD-V4600/XAP,ABS,-,-,W26,
SPRING ETC-MASK;SV-C130,SUS,4.4,-,-,-,-,
CABINET-TOP;DVD-V4500,PCM,T0.5,W430,L223
SCREW-BH;-,-,FE,FZY,BH,-,-,4*12,-,SCREW-TAPTITE;BH,+,B,M3,L10,BLK ,SWCH101
SCREW-TAPTITE;-,-,L12,ZPC3,+,-,M3,-,SWRC
CBF POWER CORD;KKP-211,VFF0.75MM,JIS,CON
CBF POWER CORD;KKP-419C,H03VVH2-F,VDE/KE
ASSY PCB-MAIN VCR;DVD-V4300/XAX,LED-M
ASSY PCB-MAIN DVD;DVD-V4500,VENUS,SEA
ASSY PCB-SMPS;DVD-V4300/XAX,FREE
ASSY SORT-FUNCTION;DVD-V4700,04-SECCOM43
ASSY SORT-FUNCTION;DVD-V4600,04-SECCOM43
HOLDER-LED;X-11,POM(K300),-,-,-,NTR,HOLDER-TR;X-11,POM(K300),-,-,-,NTR,ASSY-CON BOARD;HIPS 94HB,DVD-V4800,DVD-V
REMOCON-ASSY;DVD-V3000/XAA,SAMSUNG,-,-,4
Remark
DVD-V4300 Only
DVD-V4600 Only
DVD-V4300 Only
DVD-V4600 Only
DVD-V4300 Only
DVD-V4600 Only
Other Only
CHILE/PERU Only
DVD-V4300 Only
DVD-V4600 Only
3-3
Exploded View and Parts List
3-2 VCR Mechanical Parts (Top Side)
G001
K490
K502
K530
G530
G555
B474
G450
G510
G420
B473
G480
K546
K250
K240
K248
B411
B410
K350
K110
B440
K182
B448
K340
K330
B452
G546
K470
K140
K188
G527
G070
G520
G060
3-4
Samsung Electronics
Exploded View and Parts List
Loc. No
B410
B411
B440
B448
B452
B473
B474
G001
G060
G070
G420
G450
G480
G510
G520
G527
G530
G546
G555
G560
K110
K140
K182
K188
K240
K248
K250
K330
K340
K350
K470
K490
K502
K530
K546
Parts No.
AC97-02354A
AC71-00004A
AC60-10515A
AC66-00008A
AC66-00011A
AC61-00105A
AC61-30180A
AC97-02191A
6006-001092
AC70-00002A
AC66-80142A
AC66-80141A
AC97-01660A
6006-001075
AC66-00074A
AC61-60553A
AC33-00007A
AC66-00005A
AC97-02293A
AC97-02215A
AC66-10267A
AC66-10268A
AC66-30524A
AC66-00039A
AC66-00035A
AC61-00107A
AC69-00104A
AC66-30550A
AC66-30549A
AC61-00106A
AC66-00020A
AC61-00120A
AC61-60561A
AC66-00034A
AC61-50658A
Samsung Electronics
Description ; Specification
Remark
ASSY-LOADING MOTOR;ASSY-LOADING MOTOR,
WIRE-LOADING;X-11,PVC+ WIRE,T0.38,0.88,
SCREW-MACHINE;-,-,M3,L3,PH,+,-,-,ZPC,GEAR-WORM WHEEL;TS-10,POM,0.8,40,-,NAT,3
GEAR-FL CAM;TS-10,POM,0.8,59,-,BLK,48.48
SPRING ETC-PINCH DRIVE;TS-10,SUS304-WPB,
PLATE-JOINT;X-9,SECC20/20,T0.8,-,-,-,ASSY-CYLINDER;6ANJ(Alps Head),CX11-DS,Fo
SCREW-ASS’Y MACH;WS,PH,+,M3.0,L6.0,ZPC(Y
PLATE-GND DECK;X-11,SPTE,T0.3,-,-,-,SLIDER-SUPPLY ASSY;X-9,SUS,-,-,-,SIL,SLIDER-TAKE UP ASSY;X-9,SUS,-,-,-,SIL,ASSY-HEAD ACE;-,SCORPIO2(TS-10A),VTR-1*2
SCREW-ASS’Y TAPT;WSP,PH,+,M2.6,L5.0,ZPC(
LEVER-GUIDE(#9);TS-9,PPS,-,-,-,-,BLK,KHA
SPRING ETC-GUIDE 9;X-9,SUS304-WPB,0.25,HEAD-FE;-,-,HVFHPOO43A,-,LEVER-FL DOOR;TS-10,POM,-,-,-,-,NAT,ASSY-UNIT PINCH;SECC+SUS304,TS-10,FOR XASSY-POST #8 GUIDE;SUS303+POM(M90-44)EQ,
REEL-DISK S;X-9,POM,-,-,-,-,-,REEL-DISK T;X-9,POM,-,-,-,-,-,LEVER-IDLER;-,POM,-,-,-,-,BLK,GEAR-IDLE;TS-10,PET K3372,0.5,-,-,NTR,28
LEVER-TENSION ASS’Y;TS-10,SECC E20/20+SU
SPRING ETC-TENSION LEVER;TS-10,SUS304-WP
BAND-BRAKE ASS’Y;TS-10,-,-,-,-,-,LEVER-S.BRAKE ASSY;-,POM+SUS,-,-,-,X-9
LEVER-T.BRAKE ASSY;-,POM+SUS,-,-,-,X-9
SPRING ETC-BRAKE;TS-10,SUS304-WPB,-,-,-,
SLIDER-FL DRIVE;TS-10,SECC ,T1.0,-,-,SIL
HOLDER-FL CASS. ASS’Y;TS-10,-,-,-,-,-,SPRING ETC-FL.LEVER-LR;X-9,SUS304 WPB,OD
LEVER-FL ARM ASS’Y;TS-10,-,-,-,-,-,-,GUIDE-CASS. DOOR;X-9,POM,-,-,-,NTR
3-5
Exploded View and Parts List
3-3 VCR Mechanical Parts (Bottom Side)
G542
B462
B456
B460
B560
B500
B458
B464
B488
B484
B468
B475
K222
K200
K225
K221
B478
B570
3-6
Samsung Electronics
Exploded View and Parts List
Loc. No
B456
B458
B460
B462
B464
B468
B475
B478
B484
B488
B500
B560
B570
G542
K200
K221
K222
K225
Parts No.
AC66-00076A
AC66-00077A
AC61-00338A
AC60-10517A
AC66-00075A
AC66-00017A
AC66-00085A
AC66-00016A
AC66-00078A
AC97-02195A
AC97-02196A
AC81-00004A
AC60-10514A
AC66-60051A
AC61-21012A
AC66-20581A
AC60-30306A
AC66-00006A
Samsung Electronics
Description ; Specification
Remark
GEAR-JOINT 1;X-11,POM(K300),-,-,-,BLUE,GEAR-JOINT 2;X-11,POM(K300),-,-,-,BLUE,BRACKET-GEAR;X-11,SECC,T0.8,W20,L20,NTR,
SCREW-TAP TITE;-,-,M2.6,L5,PH,+,-,-,ZPC,
SLIDER-CAM;X-11,SECC ,T1.2,-,-,SIL,LEVER-PINCH DRIVE;TS-10,SECC E20/20,1.0
DAMPER-CAPSTAN;X-11,POM(M90-44),-,-,-,-,
LEVER-TENSION DRIVE;TS-10,SECC E20/20,1
GEAR-LOADING DRIVE;X-11,POM(K300),-,-,-,
ASSY-LEVER LOADING S;SECC+POM+SUS,X-11,F
ASSY-LEVER LOADING T;SECC+POM+SUS,X-11,F
MOTOR-CAPSTAN;THRUST END PLAY-0.2,MR-FG
SCREW-CAPSTAN;-,-,M2.6,L6,PH,+,-,-,-,BELT-PULLEY;-,5CM-70,2 * 2,-,71.3,-,X-9
HOLDER-CLUTCH ASSY;X-9,ABS,-,-,-,BLK,GEAR-CENTER ASSY;X-9,POM,M=O.5,-,-,GRY,FASTENER-WASHER SLIT;-,-,ID2.1,OD5.0,T0.
LEVER-UP DOWN;TS-10,POM,-,-,-,-,NAT,-
3-7
Exploded View and Parts List
3-4 DVD Mechanical Parts
H212
H102
H205
H900
H204
H202
H903
H903
H210
H211
H207
H241
H206
H206
H904
H904
H203
H209
H107
H105
H106
H103
H903
H108
H104
H109
3-8
Samsung Electronics
Exploded View and Parts List
Loc. No
H102
H103
H104
H105
H106
H107
H108
H109
H202
H203
H204
H205
H206
H207
H209
H210
H211
H212
H241
H900
H903
H904
Parts No.
AH66-00111B
AK66-00042A
AK97-00608A
6602-001076
AK66-00041A
AK66-00045A
AK63-00101B
AK92-00328B
AK73-00005B
AH61-50327A
AK66-00043A
AK66-00044A
AK61-00032A
AK31-00014A
AK64-00491A
AK31-00005A
AK97-00638A
AK61-00253A
AK41-00156B
6003-001157
6001-001370
6002-001086
Samsung Electronics
Description ; Specification
Remark
CLAMPER-ASSY;DP-5,POM,-,-,-,-,BLK,GEAR-PULLEY;DP-15,POM,-,-,-,WHT,-,-,ASSY-MOTOR LOAD;-,DP-15,BELT-RECTANGULAR;CR,T1.2,4.3%,1.2X25.1,B
GEAR-TRAY;DP-15,POM,-,-,-,WHT,-,-,SLIDER HOUSING;DP-15,POM,-,W17.8,L90,WHT
TRAY-DISC;DP-15,ABS,-,W120,L186.3,-,GRY,
ASSY PCB-DECK;DP-15,COMBO
RUBBER-INSULATOR;DP-15,BUTYL,•’12,HS30,H
SHAFT-P/U;DP-3,SUS,L84.7,OD3,-,-,GEAR-FEED A;DP-15,POM,-,-,-,-,-,-,GEAR-FEED B;DP-15,POM,-,-,-,-,-,-,HOLDER-CAM SKEW;DP-9,POM,-,-,-,BLACK,MOTOR SPINDLE;DP-15,3000RPM,-,-,-,CHASSIS SUB;DP-15,POM,-,-,-,-,MOTOR-FEED ASSY;-,DP-9,-,-,-,-,-,-,-,-,ASSY-PICK UP;-,SOH-DT2,TRINO ASSY PICK U
HOLDER-CHUCK;DP-15,POM,-,-,-,-,FFC-PU;DP-15,-,FFC,24,T0.3,RIGHT
SCREW-TAPTITE;PWH,+,B,M2,L6,ZPC(YEL),SWR
SCREW-MACHINE;CH,+,M1.7,L3.0,ZPC(YEL),SW
SCREW-TAPPING;PH,+,B,M1.7,L5.0,ZPC(YEL),
3-9
Exploded View and Parts List
MEMO
3-10
Samsung Electronics
4. Electrical Parts List
Loc.No
601
AC14
AC21
AC22
AC23
AC24
AC25
AC26
AC27
AC9
AD1
AD2
AE11
AE12
AE13
AE14
AE3
AE5
AIC4
AQ1
AQ2
AQ3
AQ4
AQ5
AQ6
AR14
AR15
AR16
AR17
AR28
AR29
AR30
AR31
AR41
AR42
AR43
AR44
AR45
AR46
AR47
AR48
AR49
AR50
C1P102
C1P111
C1P112
C1P114
C1P116
C1P117
C1P118
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C311
Part No
AK92-00387D
2203-001607
2203-000315
2202-002037
2203-000125
2203-005148
2203-000315
2203-000125
2203-005148
2203-001607
0407-000114
0407-000114
2401-000918
2401-003107
2401-000918
2401-003107
2401-000918
2401-000918
1201-000163
0504-000128
0504-000156
0501-000341
0504-000128
0504-000156
0501-000341
2007-000090
2007-000074
2001-000281
2001-000429
2007-000090
2007-000074
2001-000281
2001-000429
2007-001179
2007-000078
2007-000092
2007-000097
2007-000097
2007-001179
2007-000078
2007-000092
2001-000786
2007-000097
2401-001479
2401-000414
2401-001250
2401-001730
2401-003107
2203-000257
2401-002075
2203-005065
2203-006243
2203-005065
2203-000405
2203-005065
2203-005148
2401-001502
2401-000909
2401-000408
2203-005065
2401-000408
Samsung Electronics
Description ; Specification
ASSY PCB-MAIN VCR;DVD-V4300/XAX,LED-M
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;0.12NF,5%,50V,C0G,TP,1608
C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V
C-CER,CHIP;1.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.12NF,5%,50V,C0G,TP,1608
C-CER,CHIP;1.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
DIODE-ARRAY;DAN202K,80V,100mA,CA2-3,SOTDIODE-ARRAY;DAN202K,80V,100mA,CA2-3,SOTC-AL;22uF,20%,16V,GP,-,6.3x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-AL;22uF,20%,16V,GP,-,6.3x7,5
IC-OP AMP;4560,SOP,8P,173MIL,DUAL,100V/m
TR-DIGITAL;-,NPN,200MW,22K/22K,SOT-23,TP
TR-DIGITAL;KSR2103,PNP,200MW,22K/22K,SOT
TR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-DIGITAL;-,NPN,200MW,22K/22K,SOT-23,TP
TR-DIGITAL;KSR2103,PNP,200MW,22K/22K,SOT
TR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTR-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;8.2Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;8.2Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;47Kohm,5%,1/10W,TP,1608
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;10uF,20%,16V,GP,TP,4x7,5
C-AL;4.7uF,20%,35V,GP,TP,4x5,5
C-AL;10UF,20%,50V,GP,TP,5X11,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;4.7uF,20%,50V,GP,TP,5x11,5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;0.36NF,10%,50V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;0.18NF,5%,50V,C0G,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-AL;22uF,20%,16V,GP,TP,5x5,2.5
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
Remark
Loc.No
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C340
C342
C343
C344
C345
C346
C347
C348
C349
C350
C351
C352
C353
C354
C355
C356
C357
C358
C359
C360
C371
C372
C401
C402
C403
C405
C406
C407
C408
C501
C502
C503
C504
C505
Part No
2203-000257
2401-000408
2203-005065
2203-005065
2203-005065
2203-005065
2202-000797
2202-000797
2203-000257
2401-001502
2203-005148
2203-005065
2203-000257
2203-005065
2203-002398
2203-005065
2401-001502
2203-000257
2203-000975
2203-000975
2203-000975
2203-000975
2401-001502
2203-005148
2203-005065
2401-001502
2203-000257
2401-000918
2401-001169
2203-005148
2203-001587
2203-000257
2401-000414
2203-000491
2203-001052
2401-001250
2203-001103
2203-001211
2203-000257
2401-001250
2203-002041
2301-000110
2401-001502
2301-000174
2203-000257
2203-000257
2203-000257
2203-001071
2203-005148
2203-005148
2203-005148
2203-005148
2401-001479
2203-000257
2203-002398
2401-001730
2203-001724
2202-002037
2401-000408
2203-005065
2401-000909
Description ; Specification
Remark
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5S,TP,
C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5S,TP,
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;22nF,10%,50V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-AL;33UF,20%,16V,GP,-,6.3X7,5
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;18nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;10uF,20%,16V,GP,TP,4x7,5
C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;0.56nF,10%,50V,X7R,TP,1608
C-AL;4.7uF,20%,35V,GP,TP,4x5,5
C-CER,CHIP;6.8nF,10%,50V,X7R,TP,1608,C-CER,CHIP;8.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;4.7uF,20%,35V,GP,TP,4x5,5
C-CER,CHIP;0.47nF,10%,50V,X7R,TP,1608
C-FILM,LEAD-PEF;1.8nF,5%,100V,TP,7x3.0x6
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-FILM,LEAD-PEF;15nF,5%,100V,TP,7.2x4.0x
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;0.056NF,5%,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;22nF,10%,50V,X7R,TP,1608
C-AL;10UF,20%,50V,GP,TP,5X11,5
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-AL;22uF,20%,16V,GP,TP,5x5,2.5
This Document can not be used without Samsung’s authorization
4-1
Electrical Parts List
Loc.No
C506
C507
C508
C509
C510
C511
C512
C513
C514
C515
C516
C517
C518
C519
C520
C521
C522
C523
C524
C525
C526
C527
C528
C529
C530
C531
C532
C533
C534
C535
C536
C537
C538
C539
C540
C541
C542
C543
C544
C545
C546
C547
C548
C549
C550
C602
C603
C604
C605
C606
C607
C608
C609
C610
C611
C613
C614
C615
C616
C617
C618
C619
C620
C621
C622
C623
4-2
Part No
2401-000408
2203-001724
2203-000257
2401-000909
2203-000888
2203-000257
2203-000257
2203-001724
2401-000408
2203-000257
2401-000909
2203-000888
2203-000257
2203-001724
2401-000408
2203-005065
2202-000797
2203-005065
2203-005065
2203-001634
2401-001249
2203-005065
2203-005065
2203-005065
2203-005065
2401-001502
2203-000257
2203-005065
2203-005065
2203-005148
2203-001724
2401-000918
2203-001724
2401-000918
2203-001724
2401-001250
2203-005065
2203-001724
2203-001724
2203-000257
2401-001775
2401-001324
2203-005065
2203-005065
2203-005065
2203-000257
2203-000257
2203-000257
2401-000360
2203-000257
2203-000257
2401-002165
2203-002398
2203-000975
2203-000783
2401-003107
2203-000257
2203-000257
2203-005148
2401-001502
2203-000552
2203-000552
2203-000681
2203-000626
2203-005065
2202-000121
Description ; Specification
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;22uF,20%,16V,GP,TP,5x5,2.5
C-CER,CHIP;4.7nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;22uF,20%,16V,GP,TP,5x5,2.5
C-CER,CHIP;4.7nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5S,TP,
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;33nF,10%,50V,X7R,TP,1608,1.6m
C-AL;4.7uF,20%,35V,GP,TP,4x5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-AL;4.7uF,20%,35V,GP,TP,4x5,5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-CER,CHIP;4700NF,+80-20%,16V,Y5V,TP,321
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;470nF,20%,50V,GP,TP,4x7,5
C-AL;0.47UF,20%,50V,GP,BK,3X5,2.5
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;100uF,20%,50V,GP,TP,8x11.5,5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-CER,CHIP;22nF,10%,50V,X7R,TP,1608
C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;0.02NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.02NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.022nF,5%,50V,C0G,TP,1608
C-CER,CHIP;1000nF,+80-20%,10V,Y5V,-,1608
C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP
Remark
Loc.No
C624
C625
C626
C627
C628
C629
C630
C631
C632
C633
C634
C635
C636
C643
C644
C653
C657
C6B01
C701
C702
C703
C704
C801
C802
C803
C804
C811
C815
C829
C831
C832
CN101
CN102
CN301
CN302
CN303
CN303B
CN604
CN701
D1P107
D1P108
D601
D603
D604
D605
D606
D607
D701
D702
D703
D704
D801
DOC3
DOC4
DOIC2
DOL1
DOL2
DOR1
DOR2
DOR3
DT701
IC301
IC501
IC601
IC603
IC6B1
Part No
2401-002165
2202-000797
2203-005148
2203-001697
2401-001168
2203-005221
2401-001502
2203-000257
2203-001071
2203-000140
2203-001071
2203-000257
2202-000797
2203-000257
2203-000257
2203-000257
2203-000257
2401-002259
2203-000440
2203-000257
2401-002165
2401-000677
2401-003107
2401-000408
2401-000408
2203-000257
2203-000440
2401-001479
2203-000715
2203-000715
2401-003107
3711-005565
3711-001246
3708-000391
AC37-00028A
3708-001165
3809-001206
AC37-00027A
3711-005312
0401-000101
0401-000101
0401-000101
0402-000127
0402-000127
0401-000101
0402-000127
0402-000127
0401-000101
0401-000101
0401-000101
0401-000101
0401-000101
2203-005148
2203-005148
3707-001065
2901-001125
3301-001419
2007-000402
2007-000402
2007-000075
AK07-00013A
1204-001952
1204-002222
AC09-00489A
1103-001330
AC14-12009W
Description ; Specification
Remark
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5S,TP,
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.082nF,5%,50V,NP0,TP,1608
C-AL;33uF,20%,16V,GP,TP,6.3x5,2.5mm
C-CER,CHIP;15nF,10%,50V,X7R,TP,1608,C-AL;47uF,20%,16V,GP,TP,6.3x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;0.056NF,5%,50V,C0G,TP,1608
C-CER,CHIP;1.5nF,10%,50V,X7R,TP,1608,C-CER,CHIP;0.056NF,5%,50V,C0G,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5S,TP,
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;0.1F,+80-20%,5.5V,-,TP,12.5x11
C-CER,CHIP;1nF,10%,50V,X7R,TP,1608,C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;2200uF,20%,10V,GP,TP,10x20mm,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-AL;10uF,20%,16V,GP,TP,3.5x5,2.5
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;1nF,10%,50V,X7R,TP,1608,C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-CER,CHIP;3.3nF,10%,50V,X7R,TP,1608,C-CER,CHIP;3.3nF,10%,50V,X7R,TP,1608,C-AL;47uF,20%,16V,GP,TP,5x7,5
CONNECTOR-HEADER;NOWALL,24P,1R,2mm,STRAI
CONNECTOR-HEADER;NOWALL,12P,1R,2.5mm,STR
CONNECTOR-FPC/FFC/PIC;10P,1.25MM,STRAIGH
CONNECTOR-SOCKET;-,X-11,T9.0,W8.5,PBT NT
CONNECTOR-FPC/FFC/PIC;6P,1.25MM,STRAIGHT
CABLE-FLAT;30V,-20to+80C,140mm,6P,1.25mm
CONNECTOR-HEADER;20045WS,X-11,T8.5,W17.4
CONNECTOR-HEADER;3WALL,6P,1R,2MM,STRAIGH
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-RECTIFIER;1N4002,100V,1A,DO-41,TP
DIODE-RECTIFIER;1N4002,100V,1A,DO-41,TP
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-RECTIFIER;1N4002,100V,1A,DO-41,TP
DIODE-RECTIFIER;1N4002,100V,1A,DO-41,TP
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
CONNECTOR-OPTICAL;PLUG,GP1FA550TZ,6dB,2.
FILTER-EMI ON BOARD;50V,0.5A,-,220pF,7x2
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;150ohm,5%,1/10W,TP,1608
R-CHIP;150ohm,5%,1/10W,TP,1608
R-CHIP;220ohm,5%,1/10W,TP,1608
LED DISPLAY;BCD-9029A,KAISER,40,9,4,50x2
IC-VIDEO PROCESS;LA71207,QFP,80P,14X14MM
IC-SIGNAL PROCESSOR;LA72670M-MPB,QFP,80P
IC MICOM;MN101D10G-AB3,DVD-V4500,100PIN
IC-EEPROM;S524A40X41,512x8Bit,DIP,8P,9.2
IC-RESET;PST572K,TO-92,R59-1766 2.5V
This Document can not be used without Samsung’s authorization
Samsung Electronics
Electrical Parts List
Loc.No
IC801
JACK1
JK701
JK801
L1P101
L1P103
L301
L302
L303
L304
L305
L306
L307
L308
L501
L502
L601
L602
L603
L701
L803
LD601
PIC3
PT601
PT602
Q1P107
Q1P110
Q302
Q303
Q304
Q305
Q306
Q307
Q308
Q601
Q701
Q702
Q703
Q704
Q705
Q708
Q709
Q710
Q711
Q712
Q713
Q714
Q715
Q801
R1P102
R1P109
R1P111
R301
R302
R303
R304
R305
R306
R308
R309
R310
R311
R312
R313
R314
R315
Part No
1204-001927
3722-002115
3722-001943
3722-001814
2701-000002
2701-000002
AC27-92001M
3301-000297
3301-000297
3301-000297
AC27-92001M
2702-000120
2701-000002
2702-000166
3301-000297
3301-000297
2702-000108
2701-000002
2701-000002
2701-000002
2701-000002
0601-001817
1203-003216
0604-001275
0604-001275
0501-000362
0501-000362
0501-000002
0501-000341
0501-000002
0501-000442
0501-000002
0501-000442
0501-000442
0504-000129
0501-000290
0501-000290
0501-000290
0501-000290
0501-000290
0501-000341
0501-000341
0501-000341
0501-000341
0501-000341
0501-000341
0501-000341
0501-000341
0501-000002
2001-000008
2001-000062
2001-000062
2007-000092
2007-001056
2007-000079
2007-000079
2001-000734
2001-000362
2007-000106
2007-000105
2007-000124
2007-001114
2007-000122
2001-000258
2007-000123
2007-001179
Samsung Electronics
Description ; Specification
IC-AUDIO PROCESSOR;MM1501,SOT,6P,-,PLAST
JACK-PIN;6P(6C),NI,GR/RE/WH/BLK/BLU,ANG
JACK-PIN;3P,8.3PI,NI,BLK,JACK-PIN;6P,3.5MM,NI,BLK,INDUCTOR-AXIAL;100UH,10%,4298
INDUCTOR-AXIAL;100UH,10%,4298
COIL-INDUCTOR;RH3.5X6.5RS,BEAD(RADIAL),BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
COIL-INDUCTOR;RH3.5X6.5RS,BEAD(RADIAL),INDUCTOR-RADIAL;15000uH,5%,6.2x7.4mm
INDUCTOR-AXIAL;100UH,10%,4298
INDUCTOR-RADIAL;47uH,5%,6.0x6.4mm
BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
INDUCTOR-RADIAL;100uH,5%,6.0x6.4mm
INDUCTOR-AXIAL;100UH,10%,4298
INDUCTOR-AXIAL;100UH,10%,4298
INDUCTOR-AXIAL;100UH,10%,4298
INDUCTOR-AXIAL;100UH,10%,4298
LED-IR;SIDE-VIEW,2.5mm,75mW,6V,940,TR
IC-POSI.FIXED REG.;G9133,TO-220F,4P,10.1
PHOTO-INTERRUPTER;-,-,-,SNAP,TR
PHOTO-INTERRUPTER;-,-,-,SNAP,TR
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
TR-SMALL SIGNAL;KSA812,PNP,150MW,SOT-23,
TR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSA812,PNP,150MW,SOT-23,
TR-SMALL SIGNAL;KTC3203-Y,NPN,400mW,T0-9
TR-SMALL SIGNAL;KSA812,PNP,150MW,SOT-23,
TR-SMALL SIGNAL;KTC3203-Y,NPN,400mW,T0-9
TR-SMALL SIGNAL;KTC3203-Y,NPN,400mW,T0-9
TR-DIGITAL;KSR1104,NPN,200mW,47K/47K,SOT
TR-SMALL SIGNAL;KSA643-Y,PNP,500mW,TO-92
TR-SMALL SIGNAL;KSA643-Y,PNP,500mW,TO-92
TR-SMALL SIGNAL;KSA643-Y,PNP,500mW,TO-92
TR-SMALL SIGNAL;KSA643-Y,PNP,500mW,TO-92
TR-SMALL SIGNAL;KSA643-Y,PNP,500mW,TO-92
TR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSA812,PNP,150MW,SOT-23,
R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;470OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CARBON;470OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;6.2Kohm,5%,1/10W,TP,1608
R-CHIP;1.8Kohm,5%,1/10W,TP,1608
R-CHIP;1.8Kohm,5%,1/10W,TP,1608
R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;150OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;220Kohm,5%,1/10W,TP,1608
R-CHIP;200Kohm,5%,1/10W,TP,1608
R-CHIP;2.2Kohm,5%,1/10W,TP,1608
R-CHIP;680Kohm,5%,1/10W,TP,1608
R-CHIP;1.2Kohm,5%,1/10W,TP,1608
R-CARBON;1.8KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CHIP;1.5Kohm,5%,1/10W,TP,1608
R-CHIP;8.2Kohm,5%,1/10W,TP,1608
Remark
Loc.No
R316
R317
R318
R319
R320
R322
R326
R327
R328
R329
R330
R331
R332
R333
R334
R335
R336
R338
R339
R340
R341
R342
R343
R344
R345
R346
R348
R3D05
R3D06
R401
R402
R501
R502
R503
R504
R505
R506
R507
R508
R509
R510
R512
R513
R514
R515
R516
R517
R518
R523
R524
R525
R526
R527
R528
R601
R602
R603
R604
R605
R606
R607
R609
R611
R613
R614
R615
Part No
2001-000290
2001-000387
2001-000387
2001-000290
2007-000079
2007-000082
2007-000122
2007-000070
2007-000127
2007-000133
2007-000402
2007-000129
2007-000078
2001-000221
2007-000094
2007-000097
2007-000090
2007-000074
2007-000124
2007-000124
2001-000522
2007-000090
2007-001002
2007-001002
2001-000429
2007-000078
2007-000086
2007-000124
2001-000800
2007-000121
2007-000121
2007-000090
2007-000088
2007-000092
2007-000097
2001-000786
2007-000077
2007-000081
2007-000130
2001-000780
2001-000780
2007-000088
2001-000786
2001-000786
2007-000092
2007-000078
2007-000078
2007-000084
2007-000088
2001-000786
2001-000786
2007-000088
2007-000091
2007-000805
2007-000094
2001-000034
2007-000094
2001-000034
2001-000111
2001-000522
2001-000633
2001-000429
2001-000472
2001-000290
2001-000429
2007-000086
Description ; Specification
Remark
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;16KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;16KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;1.8Kohm,5%,1/10W,TP,1608
R-CHIP;3.3Kohm,5%,1/10W,TP,1608
R-CHIP;1.2Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;9.1Kohm,5%,1/10W,TP,1608
R-CHIP;330Kohm,5%,1/10W,TP,1608
R-CHIP;150ohm,5%,1/10W,TP,1608
R-CHIP;27Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CARBON;1.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CHIP;22Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;2.2Kohm,5%,1/10W,TP,1608
R-CHIP;2.2Kohm,5%,1/10W,TP,1608
R-CARBON;22KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;510ohm,5%,1/10W,TP,1608
R-CHIP;510ohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;2.2Kohm,5%,1/10W,TP,1608
R-CARBON;5.1KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CHIP;820ohm,5%,1/10W,TP,1608
R-CHIP;820ohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;7.5Kohm,5%,1/10W,TP,1608
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;470ohm,5%,1/10W,TP,1608
R-CHIP;2.7Kohm,5%,1/10W,TP,1608
R-CHIP;39Kohm,5%,1/10W,TP,1608
R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;7.5Kohm,5%,1/10W,TP,1608
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;7.5Kohm,5%,1/10W,TP,1608
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;7.5Kohm,5%,1/10W,TP,1608
R-CHIP;12Kohm,5%,1/10W,TP,1608
R-CHIP;36Kohm,5%,1/10W,TP,1608
R-CHIP;22Kohm,5%,1/10W,TP,1608
R-CARBON;220OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CHIP;22Kohm,5%,1/10W,TP,1608
R-CARBON;220OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CARBON;150OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CARBON;22KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;30KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
This Document can not be used without Samsung’s authorization
4-3
Electrical Parts List
Loc.No
R616
R617
R618
R619
R621
R622
R623
R624
R630
R631
R632
R633
R634
R638
R639
R641
R643
R644
R645
R646
R647
R648
R649
R650
R651
R652
R653
R656
R660
R661
R662
R664
R666
R667
R668
R669
R670
R671
R677
R679
R680
R690
R691
R692
R694
R6A01
R6B01
R701
R702
R703
R704
R705
R706
R707
R708
R710
R711
R712
R713
R714
R715
R716
R717
R718
R719
R720
4-4
Part No
2001-000429
2007-000122
2007-000098
2001-000290
2007-000077
2007-000077
2007-000084
2007-000084
2007-000098
2007-000098
2007-000097
2007-000106
2007-000070
2007-000082
2007-000081
2001-000290
2007-000090
2007-000090
2007-000090
2007-000086
2007-000076
2007-000076
2007-000084
2007-000084
2007-000084
2007-000090
2001-000429
2001-000290
2007-000100
2007-000078
2001-000290
2001-000429
2001-000281
2001-000281
2007-000078
2007-000074
2007-000074
2007-000074
2001-000429
2001-000429
2001-000429
2001-000429
2001-000429
2001-000429
2007-000078
2007-000090
2001-000568
2001-000429
2007-000092
2001-000429
2007-000092
2001-000429
2007-000092
2001-000429
2007-000092
2007-001167
2007-000090
2001-000449
2001-000449
2001-000449
2001-000449
2001-000449
2001-000290
2001-000290
2001-000290
2001-000290
Description ; Specification
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;1.2Kohm,5%,1/10W,TP,1608
R-CHIP;56Kohm,5%,1/10W,TP,1608
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;470ohm,5%,1/10W,TP,1608
R-CHIP;470ohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;56Kohm,5%,1/10W,TP,1608
R-CHIP;56Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;220Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;3.3Kohm,5%,1/10W,TP,1608
R-CHIP;2.7Kohm,5%,1/10W,TP,1608
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;330ohm,5%,1/10W,TP,1608
R-CHIP;330ohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;68Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CARBON;27OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
Remark
Loc.No
R721
R722
R723
R724
R728
R729
R730
R731
R732
R733
R734
R735
R804
R806
R810
R811
R812
RM702
S602
SJACK
SW602
SW603
SW704
SW705
SW706
SW707
SW709
TM401
VC10
VC11
VC13
VC14
VC15
VC16
VC17
VC18
VC50
VC6
VC7
VC8
VC9
VE1
VE2
VE4
VE5
VE6
VE7
VIC1
VJ5
VR29
VR30
VR31
VR32
VR33
VR34
XT301
XT601
XT602
ZD1P05
ZD1P06
ZD401
Part No
2001-000290
2001-000290
2001-000290
2001-000290
2007-001167
2007-001167
2007-001167
2007-001167
2007-001167
2007-001167
2007-001167
2007-001167
2007-001167
2007-000078
2007-000097
2007-000097
2001-000025
0609-001198
0603-001134
3722-001375
AC34-00006A
AC34-00005A
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
AC40-00025B
2203-005148
2203-005148
2203-001607
2203-001607
2203-001607
2203-001607
2202-002037
2203-001607
2203-005148
2203-005148
2202-002037
2202-002037
2203-005148
2401-002165
2401-000918
2401-001479
2401-001479
2401-001479
2401-001479
1204-001978
2007-000070
2007-000084
2007-001164
2007-001164
2007-001164
2007-001164
2007-001164
2801-003399
2801-001384
2801-003318
0403-000720
0403-000717
0403-000390
Description ; Specification
Remark
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;75ohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CARBON;75OHM,5%,1/4W,AA,TP,2.4X6.4MM
MODULE REMOCON;VERTICAL,-,TR
PHOTO TR;-,30V,4V,50mA,75mW,TRAY
JACK-DIN;4P,-,NI,BLK,SWITCH-REC;-,-,-,-,-,-,-,-,-,-,-,-,-,-,SWITCH MODE;-,-,-,-,-,-,-,-,-,-,-,-,-,-,
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
TM BLOCK;VH015AP,NTSC-M,181CH,-,25DB,5V
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V
C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;22uF,20%,16V,GP,-,6.3x7,5
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;470UF,20%,10V,GP,TP,6.3*11MM,IC-VIDEO PROCESS;LA73054,-,36P,-,SSOP,7V
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
CRYSTAL-UNIT;3.579545MHz,15ppm,28-AAA,S,
CRYSTAL-UNIT;14.31818MHz,30ppm,28-AAA,16
CRYSTAL-UNIT;32.768KHz,20ppm,28-AAP,12.5
DIODE-ZENER;MTZJ9.1B,8.57-9.01V,500MW,DO
DIODE-ZENER;MTZJ5.1B,4.94-5.2V,500MW,DODIODE-ZENER;UZP33B,31.4-34.6V,1000MW,DO-
This Document can not be used without Samsung’s authorization
Samsung Electronics
Electrical Parts List
Loc.No
602
AC18
AC19
AC20
AE10
AE8
AIC2
AL1
AR101
AR102
AR103
AR104
CN4
CNC1
CNC2
CNC3
CNC4
CNC5
CNR1
CNR2
CNR3
CNR4
CNR5
CNR6
DCN1
DCN2
DOC1
DOC2
DOR3
DQ1
DQ2
DQ3
DR1
DR2
DR3
DR4
DR5
DR6
FC1
FC10
FC11
FC12
FC2
FC3
FC4
FC5
FC6
FC8
FC9
FE1
FE2
FE3
FIC1
FL1
FR1
FR10
FR11
FR12
FR13
FR14
FR15
FR16
FR17
FR18
FR19
FR2
Part No
AK92-00341A
2203-005148
2203-005148
2203-005148
2401-002165
2401-002165
1002-001294
3301-001419
2007-000070
2007-000070
2007-000070
2007-000070
3710-002050
2203-000681
2203-000681
2203-000681
2203-000681
2203-000681
2007-000074
2007-000074
2007-000074
2007-000074
2007-000074
2007-000074
3708-001696
3708-001266
2203-000257
2203-005148
2007-000070
0501-000341
0501-000341
0501-000341
2007-000090
2007-000090
2007-000078
2007-000090
2007-000090
2007-000075
2203-000257
2203-005148
2203-001607
2203-005148
2203-001607
2203-000257
2203-000669
2203-000140
2203-000669
2203-005148
2203-000257
2401-003107
2401-001479
2401-003107
1003-001661
3301-001419
2007-000100
2007-000092
2007-000093
2007-000329
2007-000092
2007-000078
2007-000655
2007-007277
2007-000090
2007-000127
2007-000090
2007-000090
Samsung Electronics
Description ; Specification
ASSY PCB-MAIN DVD;DVD-V4500,VENUS,SEA
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
IC-D/A CONVERTER;PCM1742KE,24BIT,TSSOP,1
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
CONNECTOR-SOCKET;12P,1R,2mm,STRAIGHT,SN,
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
CONNECTOR-FPC/FFC/PIC;24P,1MM,STRAIGHT,S
CONNECTOR-FPC/FFC/PIC;11P,1MM,STRAIGHT,S
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
TR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTTR-SMALL SIGNAL;KSC1623-L,NPN,200mW,SOTR-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;220ohm,5%,1/10W,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;27nF,10%,25V,X7R,TP,1608,C-CER,CHIP;1.5nF,10%,50V,X7R,TP,1608,C-CER,CHIP;27nF,10%,25V,X7R,TP,1608,C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;47uF,20%,16V,GP,TP,5x7,5
IC-MOTOR DRIVER;FAN8004,HQFP,48P,13.2x13
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;68Kohm,5%,1/10W,TP,1608
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;20Kohm,5%,1/10W,TP,1608
R-CHIP;11Kohm,5%,1/10W,TP,1608
R-CHIP;15Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;27Kohm,5%,1/10W,TP,1608
R-CHIP;392ohm,1%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;9.1Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
Remark
Loc.No
FR20
FR21
FR22
FR23
FR24
FR25
FR26
FR28
FR3
FR30
FR31
FR32
FR33
FR34
FR35
FR36
FR37
FR39
FR4
FR41
FR5
FR7
FR8
FR9
JJ1
JJ2
JJ3
JJ4
PC1
PC4
PC5
PC6
PC8
PE1
PE3
PE4
PE6
PIC1
PL1
PL3
PL4
PR1
RC10
RC11
RC12
RC13
RC14
RC15
RC16
RC17
RC18
RC19
RC2
RC20
RC21
RC22
RC23
RC24
RC25
RC28
RC29
RC30
RC31
RC32
RC33
RC34
Part No
2007-000090
2007-000070
2007-000070
2007-000086
2007-000086
2007-000086
2007-000094
2007-007277
2007-000100
2007-000070
2007-000134
2007-000070
2007-000091
2007-000134
2007-000070
2007-000091
2007-000084
2007-000087
2007-000094
2007-000082
2007-000086
2007-000086
2007-000086
2007-000090
3301-001419
2007-000033
3301-001419
2007-000033
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2401-002165
2401-002165
2401-002165
2401-002165
1203-002779
2007-000033
2703-000398
2007-000033
2007-000070
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-001662
2203-001662
2203-001662
2203-001052
2203-000815
2203-005148
2203-000491
2203-000491
2203-001656
2203-000491
2203-005148
2203-000491
2203-001662
2203-001662
2203-001662
2203-005148
2203-001662
2203-001662
2203-000440
Description ; Specification
Remark
R-CHIP;10Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;22Kohm,5%,1/10W,TP,1608
R-CHIP;392ohm,1%,1/10W,TP,1608
R-CHIP;68Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;33Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;12Kohm,5%,1/10W,TP,1608
R-CHIP;33Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;12Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;6.8Kohm,5%,1/10W,TP,1608
R-CHIP;22Kohm,5%,1/10W,TP,1608
R-CHIP;3.3Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;5.6Kohm,5%,1/10W,TP,1608
R-CHIP;10Kohm,5%,1/10W,TP,1608
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;0ohm,5%,1/4W,TP,3216
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;0ohm,5%,1/4W,TP,3216
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
IC-POSI.FIXED REG.;G952T63U,SOT-223,3P,6
R-CHIP;0ohm,5%,1/4W,TP,3216
INDUCTOR-SMD;10uH,10%,3225
R-CHIP;0ohm,5%,1/4W,TP,3216
R-CHIP;0ohm,5%,1/10W,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;0.56nF,10%,50V,X7R,TP,1608
C-CER,CHIP;0.033NF,5%,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;0.47nF,5%,50V,NP0,TP,1608
C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;1nF,10%,50V,X7R,TP,1608,-
This Document can not be used without Samsung’s authorization
4-5
Electrical Parts List
Loc.No
RC35
RC36
RC37
RC4
RC5
RC6
RC7
RC8
RC9
RD1
RE1
RE2
RE5
RE6
RIC1
RL1
RL2
RL3
RQ1
RQ2
RR1
RR10
RR11
RR12
RR13
RR14
RR15
RR16
RR17
RR18
RR2
RR3
RR4
RR5
RR7
ZC10
ZC11
ZC12
ZC13
ZC14
ZC15
ZC16
ZC17
ZC18
ZC19
ZC2
ZC20
ZC21
ZC22
ZC23
ZC24
ZC25
ZC26
ZC27
ZC28
ZC29
ZC3
ZC30
ZC31
ZC32
ZC33
ZC34
ZC35
ZC36
ZC37
ZC39
4-6
Part No
2203-000257
2203-001662
2203-001662
2203-005148
2203-005148
2203-001103
2203-001634
2203-001607
2203-005148
0407-000116
2401-002165
2401-002165
2401-003107
2401-002165
AK13-00005B
2007-000033
2007-000033
2703-000398
0501-000279
0501-000279
2007-000312
2007-000234
2007-000234
2007-000234
2007-000084
2007-000084
2007-000084
2007-000091
2007-007549
2007-000052
2007-000078
2007-000078
2007-000312
2007-000084
2007-000381
2203-005148
2203-005148
2203-005148
2203-000280
2203-005148
2203-005148
2203-005148
2203-005148
2203-000815
2203-000815
2203-005148
2203-000815
2203-000815
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-000681
2203-000681
Description ; Specification
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;5.6NF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;6.8nF,10%,50V,X7R,TP,1608,C-CER,CHIP;33nF,10%,50V,X7R,TP,1608,1.6m
C-CER,CHIP;0.22nF,5%,50V,NP0,-,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
DIODE-ARRAY;DAP202K,80V,100mA,CK2-3,SOTC-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;100uF,20%,16V,GP,TP,6.3x7,5
IC ASIC;SP3723CA0PM,EXINO2,64,5,+135,Q
R-CHIP;0ohm,5%,1/4W,TP,3216
R-CHIP;0ohm,5%,1/4W,TP,3216
INDUCTOR-SMD;10uH,10%,3225
TR-SMALL SIGNAL;KSA1182-Y,PNP,150mW,SOTTR-SMALL SIGNAL;KSA1182-Y,PNP,150mW,SOTR-CHIP;10ohm,5%,1/4W,TP,3216
R-CHIP;1.3Kohm,5%,1/10W,TP,1608
R-CHIP;1.3Kohm,5%,1/10W,TP,1608
R-CHIP;1.3Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;12Kohm,5%,1/10W,TP,1608
R-CHIP;4.99Kohm,1%,1/10W,TP,1608
R-CHIP;10Kohm,1%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;1Kohm,5%,1/10W,TP,1608
R-CHIP;10ohm,5%,1/4W,TP,3216
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;13Kohm,5%,1/10W,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.01NF,0.5PF,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.033NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.033NF,5%,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.033NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.033NF,5%,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
C-CER,CHIP;0.027NF,5%,50V,C0G,TP,1608
Remark
Loc.No
ZC4
ZC40
ZC41
ZC42
ZC43
ZC44
ZC45
ZC46
ZC47
ZC48
ZC49
ZC5
ZC50
ZC51
ZC6
ZC7
ZC8
ZC9
ZE1
ZE2
ZE3
ZE4
ZE5
ZE6
ZIC1
ZIC2
ZIC3
ZIC4
ZL1
ZL11
ZL12
ZL13
ZL14
ZL2
ZL3
ZL4
ZL5
ZL6
ZL8
ZL9
ZR10
ZR11
ZR12
ZR13
ZR14
ZR15
ZR16
ZR17
ZR18
ZR19
ZR2
ZR20
ZR21
ZR22
ZR23
ZR24
ZR25
ZR26
ZR27
ZR28
ZR29
ZR30
ZR31
ZR35
ZR36
ZR46
Part No
2203-005148
2203-000257
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-005148
2203-000257
2203-005148
2203-005148
2203-000783
2203-005148
2203-005148
2203-005148
2203-005148
2401-003107
2401-003107
2401-003107
2401-003107
2401-001479
2401-001479
1204-002195
1105-001305
1107-001369
0801-002701
3301-001419
2007-000070
2007-000070
3301-001419
3301-001419
3301-001419
3301-001419
3301-001419
3301-001419
2007-000033
2007-000033
2007-000033
2007-001164
2007-001164
2007-001164
2007-001164
2007-001164
2007-001164
2007-001164
2007-007277
2007-000113
2007-000113
2007-000070
2007-000113
2007-000113
3301-001419
3301-001419
2007-000109
2007-000097
2007-000074
2007-000074
2007-000074
2007-000070
2007-000074
2007-000074
2007-000084
2007-000084
3301-001419
Description ; Specification
Remark
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;10nF,10%,50V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;470UF,20%,10V,GP,TP,6.3*11MM,IC-DECODER;ZR36762,PQFP,208P,28x28mm,PLA
IC-DRAM;4S641632,1MX16X4BIT,TSOP,54P,4
IC-FLASH MEMORY;29LV800,1Mx8/512Kx16,TSO
IC-CMOS LOGIC;74VHCT125A,BUFFER,TSSOP,14
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;0ohm,5%,1/4W,TP,3216
R-CHIP;0ohm,5%,1/4W,TP,3216
R-CHIP;0ohm,5%,1/4W,TP,3216
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;75ohm,1%,1/10W,TP,1608
R-CHIP;392ohm,1%,1/10W,TP,1608
R-CHIP;33ohm,5%,1/10W,TP,1608
R-CHIP;33ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;33ohm,5%,1/10W,TP,1608
R-CHIP;33ohm,5%,1/10W,TP,1608
BEAD-SMD;-,220,-,500,TP,-,0.3
BEAD-SMD;-,220,-,500,TP,-,0.3
R-CHIP;1Mohm,5%,1/10W,TP,1608
R-CHIP;47Kohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;100ohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
BEAD-SMD;-,220,-,500,TP,-,0.3
This Document can not be used without Samsung’s authorization
Samsung Electronics
Electrical Parts List
Loc.No
Part No
Description ; Specification
ZR47
ZR48
ZR54
ZR55
ZR56
ZR57
ZR58
ZR59
ZR7
ZR8
ZR9
ZY1
2007-000084
2007-000084
2007-000084
2007-000070
2007-000070
2007-000070
2007-000070
2007-000070
3301-001309
3301-001309
2007-001164
2801-003554
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;4.7Kohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
R-CHIP;0ohm,5%,1/10W,TP,1608
BEAD-SMD;47ohm,1.6x0.8x0.8mm,500mA,TP,BEAD-SMD;47ohm,1.6x0.8x0.8mm,500mA,TP,R-CHIP;75ohm,1%,1/10W,TP,1608
CRYSTAL-UNIT;27MHz,10ppm,28-AAM,12pF,40o
603
BD1S01
BD1SS3
C1P102
C1P103
C1P104
C1P107
C1P108
C1P110
C1SD02
C1SD11
C1SD12
C1SD13
C1SD16
C1SF01
C1SF02
C1SF04
C1SS01
C1SS03
C1SS04
C1SS05
C1SS06
C1SS07
C1SS08
C1SS10
C1SS11
C1SS12
C1SS15
C1SS16
C1SS17
C1SS18
CN103
CN1SS1
D1P103
D1P105
D1SF01
D1SF02
D1SS01
D1SS02
D1SS03
D1SS04
D1SS05
D1SS07
D1SS08
D1SS09
D1SS11
D1SS12
D1SS13
F1SS01
IC1SF1
IC1SS1
IC1SS2
L1P102
AK94-00006B
AC27-92001M
AC27-92001M
2401-002075
2401-001730
2401-000598
2401-002075
2401-003107
2401-003107
2305-001021
2401-003303
2305-001029
2305-001029
2201-000012
2201-002044
2401-002608
2401-000598
2305-001021
2201-000828
2201-000828
2201-002044
2401-002608
2401-003480
2401-001479
2401-000118
2301-000129
2401-000385
2401-001126
2401-001126
2401-000804
2401-003480
3710-002036
3711-000178
0401-000101
0401-000101
0401-000101
0402-001195
0402-001196
0402-001196
0402-001196
0402-001196
0402-001194
0404-001235
0404-001235
0402-001195
0402-000012
0402-001195
0402-001194
3601-001122
1203-002805
0604-001028
AC14-12006D
3301-000297
ASSY PCB-SMPS;DVD-V4300/XAX,FREE
COIL-INDUCTOR;RH3.5X6.5RS,BEAD(RADIAL),COIL-INDUCTOR;RH3.5X6.5RS,BEAD(RADIAL),C-AL;4.7uF,20%,50V,GP,TP,5x11,5
C-AL;10UF,20%,50V,GP,TP,5X11,5
C-AL;1uF,20%,50V,GP,TP,4x7,5
C-AL;4.7uF,20%,50V,GP,TP,5x11,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-AL;47uF,20%,16V,GP,TP,5x7,5
C-FILM,LEAD-PEF;100nF,20%,275V,TP,17.5x7
C-AL;82uF,20%,400V,GP,BK,22X30,10
C-FILM,LEAD-PEF;10nF,10%,630V,TP,12x9x12
C-FILM,LEAD-PEF;10nF,10%,630V,TP,12x9x12
C-CERAMIC,DISC;0.22NF,10%,1KV,Y5P,TP,6.3
C-CERAMIC,DISC;0.1NF,10%,400V,Y5P,TP,8.5
C-AL;33uF,20%,35V,GP,TP,5x11,5
C-AL;1uF,20%,50V,GP,TP,4x7,5
C-FILM,LEAD-PEF;100nF,20%,275V,TP,17.5x7
C-CERAMIC,DISC;3.3NF,20%,400V,Y5U,TP,15X
C-CERAMIC,DISC;3.3NF,20%,400V,Y5U,TP,15X
C-CERAMIC,DISC;0.1NF,10%,400V,Y5P,TP,8.5
C-AL;33uF,20%,35V,GP,TP,5x11,5
C-AL;1000UF,20%,10V,LZ,TP,10X16MM,5
C-AL;470UF,20%,10V,GP,TP,6.3*11MM,C-AL;1000uF,20%,10V,GP,TP,10x12.5,5
C-FILM,LEAD-PEF;100nF,5%,50V,TP,10X9X4.3
C-AL;10uF,20%,100V,GP,TP,6.3x11,5
C-AL;330uF,20%,25V,WT,TP,10x12.5,5
C-AL;330uF,20%,25V,WT,TP,10x12.5,5
C-AL;220uF,20%,16V,GP,TP,8x9mm,5
C-AL;1000UF,20%,10V,LZ,TP,10X16MM,5
CONNECTOR-SOCKET;12P,1R,2.5mm,STRAIGHT,S
CONNECTOR-HEADER;1WALL,2P,1R,3.96mm,STRA
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-SWITCHING;1N4148,75V,150MA,DO-35,T
DIODE-RECTIFIER;F1T4,400V,1A,DO-204AC,TP
DIODE-RECTIFIER;1T5,600V,1A,TS-1,TP
DIODE-RECTIFIER;1T5,600V,1A,TS-1,TP
DIODE-RECTIFIER;1T5,600V,1A,TS-1,TP
DIODE-RECTIFIER;1T5,600V,1A,TS-1,TP
DIODE-RECTIFIER;UG2D,200V,2A,-,TP
DIODE-SCHOTTKY;SHK65-45R,60V,3000mA,DO-2
DIODE-SCHOTTKY;SHK65-45R,60V,3000mA,DO-2
DIODE-RECTIFIER;F1T4,400V,1A,DO-204AC,TP
DIODE-RECTIFIER;UF4007,1KV,1A,DO-41,TP
DIODE-RECTIFIER;F1T4,400V,1A,DO-204AC,TP
DIODE-RECTIFIER;UG2D,200V,2A,-,TP
FUSE-CARTRIDGE;250V,1.6A,FAST-ACTING,GLA
IC-PWM CONTROLLER;ICE2BS01,PDIP,8P,9.52X
PHOTO-COUPLER;TR,50-600%,250mW,DIP-4,ST
IC;KA431Z,TO-92,TAPING
BEAD-AXIAL;25ohm,3.6x1.2x5.7mm,,TP,,,
Samsung Electronics
Remark
Loc.No
Part No
Description ; Specification
L1SS01
L1SS02
L1SS03
L1SS04
PT1SD1
Q1P101
Q1P102
Q1P103
Q1P104
Q1P105
Q1P106
Q1SS01
R1P101
R1P103
R1P104
R1P108
R1SD06
R1SD11
R1SD13
R1SD14
R1SF05
R1SF06
R1SF07
R1SQ11
R1SR01
R1SR02
R1SR03
R1SS01
R1SS03
R1SS04
R1SS05
R1SS06
R1SS08
R1SS11
VA1SS1
ZD1P02
ZD1P04
ZD1SS2
ZD1SS3
AC27-92001Q
AC27-12001N
AC27-12001N
AC27-12001N
AC26-00012A
0501-000362
0504-000142
0501-000398
0501-000362
0501-000362
0501-000362
0505-001729
2001-000855
2001-000362
2001-000449
2001-000062
2001-000780
2006-000273
2006-000273
2001-000598
2001-000527
2001-000449
2003-000105
2001-000281
2001-000546
2001-000546
2001-000546
2006-000262
2001-000429
2004-000869
2004-000459
2001-000290
2001-000793
2001-000281
1405-001026
0403-001211
0403-000717
0403-001318
0403-000713
COIL-LINE FILTER;-,25MH,-,-,-,-,-,-,3.2o
COIL CHOKE;10UH-15%,RA,K-30,Q80,150KHZ,COIL CHOKE;10UH-15%,RA,K-30,Q80,150KHZ,COIL CHOKE;10UH-15%,RA,K-30,Q80,150KHZ,TRANS SWITCHING;EER3530,DIVA(EUROPE),-,2
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
TR-DIGITAL;KSR2001,PNP,300MW,4.7K/4.7K,T
TR-SMALL SIGNAL;KSC945,NPN,250mW,TO-92,T
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
TR-SMALL SIGNAL;KSC2328A-Y,NPN,1000MW,TO
FET-SILICON;SPA04N60C3,N,600V,4.5A,0.85O
R-CARBON;560OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CARBON;150OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-CARBON;470OHM,5%,1/4W,AA,TP,2.4X6.4MM
R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CEMENT;27KOHM,5%,2W,CA,BK,6.4X6.5X18M
R-CEMENT;27KOHM,5%,2W,CA,BK,6.4X6.5X18M
R-CARBON;3.3OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;22OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M
R-METAL OXIDE;0.33ohm,5%,2W,AD,TP,6x16mm
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;270KOHM,5%,1/4W,AA,TP,2.4X6.4M
R-CARBON;270KOHM,5%,1/4W,AA,TP,2.4X6.4M
R-CARBON;270KOHM,5%,1/4W,AA,TP,2.4X6.4M
R-CEMENT;2.7ohm,10%,2W,CB,TP,7.5x11x20.
R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-METAL;3Kohm,1%,1/8W,AA,TP,1.8x3.2mm
R-METAL;2.2Kohm,1%,1/8W,AA,TP,1.8x3.2m
R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM
R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
VARISTOR;470V,600A,9x7mm,TP
DIODE-ZENER;MTZJ12B,11.8-12.3V,500MW,DODIODE-ZENER;MTZJ5.1B,4.94-5.2V,500MW,DODIODE-ZENER;MTZJ4.3B,4.17-4.43V,500MW,DO
DIODE-ZENER;MTZJ20B,18.63-17.7V,500MW,DO
701
AK94-00011A
AK94-00010A
3710-001918
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
3404-001182
ASSY SORT-FUNCTION;DVD-V4700,04-SECCOM43
ASSY SORT-FUNCTION;DVD-V4600,04-SECCOM43
CONNECTOR-SOCKET;6P,1R,2MM,ANGLE,SN
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
SWITCH-TACT;DC12V,50MA,100GF,6.0X6.0X5.0
CN702
SW711
SW712
SW713
SW714
SW715
SW716
SW717
SW718
SW731
SW732
SW733
SW734
SW735
SW736
SW737
SW738
This Document can not be used without Samsung’s authorization
Remark
DVD-V4300 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4600 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
DVD-V4300 Only
4-7
Electrical Parts List
MEMO
4-8
This Document can not be used without Samsung’s authorization
Samsung Electronics
Audio Common
Video Common
Super
Audio
Coaxial
Optical
DECK ASS'Y (DP-15)
Component
5. Block Diagram
Pick-up & I/V Amp
Feed Motor
AIC2
(PCM1742KE)
2CH Audio DAC
VIC1
(LA73054)
Video Amp 6CH S/W
DVD Composite
Video
IC801
(MM1501)
Output Video Signal Switch
VCR Composite Video
Disk Motor
FIC1
(FAN8004)
Motor Driver
RIC1
(S5L1463)
RF IC
ZIC1
(Vaddis 6E)
A/V Decoder
IC501
(LA72670BM)
Hi-FI Audio Processor
IC301
(LA71207)
Video Signal Processor
ZIC2 64MB SD RAM
Video IN
ZIC4
(TC74VHCT125)
Level Shifter
IC601
(MN101D10F)
VCR Main Micom
IC603 EEPROM
TR DRIVE
(Q701~Q705, Q708~Q715)
LED Drive
ZIC3
(MBM29LV800BA)
IMB Flash Memory
Front A/V Jack
(DT701)
Samsung Electronics
This Document can not be used without Samsung’s authorization
5-1
Block Diagram
MEMO
5-2
This Document can not be used without Samsung’s authorization
Samsung Electronics
6. Schematic Diagrams
◆ Block Identification of Main PCB- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-2
6-1 S.M.P.S. - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-3
6-2 Power - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-4
6-3 Logic/Function - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-5
6-4 A/V - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-6
6-5 Hi-Fi/MTS - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-7
6-6 TM/Input-Output - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-8
6-7 DVD AV-Decoder - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-9
6-8 DVD M_Drive/RF - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-10
6-9 DVD Audio_Dac - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-11
6-10 DVD Input-Output- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
6-12
Samsung Electronics
Note
For schematic Diagram
- Resistors are in ohms, 1/8W unless otherwise noted.
Special note :
Most semiconductor devices are electrostatically sensitive and therefore require the special handling techniques described under the
“electrostatically sensitive (ES) devices” section of this service manual.
Note :
Do not use the part number shown on this drawing for ordering. The correct part number is shown in the parts list (may be slightly
different or amended since this drawing was prepared).
Important safety notices :
Components identified with the mark
Use only the same type.
This Document can not be used without Samsung’s authorization
have the special characteristics for safety. When replacing any of these components.
6-1
Schematic Diagrams
◆ Block Identification of Main PCB
VCR MAIN PCB
<Component Side>
<Conductor Side>
LOGIC
DATA
DVD MAIN PCB
DVD AUDIO
DAC
DVD RF
SIGNAL BLOCK
DVD MAIN DECODER
A/V BLOCK
DVD MOTOR
DRIVE BLOCK
<Component Side>
6-2
This Document can not be used without Samsung’s authorization
Samsung Electronics
Schematic Diagrams
6-1 S.M.P.S.
Samsung Electronics
This Document can not be used without Samsung’s authorization
6-3
Schematic Diagrams
6-2 Power
6-4
This Document can not be used without Samsung’s authorization
Samsung Electronics
Schematic Diagrams
6-3 Logic/Function
Samsung Electronics
This Document can not be used without Samsung’s authorization
6-5
Schematic Diagrams
6-4 A/V
6-6
This Document can not be used without Samsung’s authorization
Samsung Electronics
Schematic Diagrams
6-5 Hi-Fi/MTS
Samsung Electronics
This Document can not be used without Samsung’s authorization
6-7
Schematic Diagrams
6-6 TM/Input-Output
6-8
This Document can not be used without Samsung’s authorization
Samsung Electronics
Schematic Diagrams
6-7 DVD AV-Decoder
Samsung Electronics
This Document can not be used without Samsung’s authorization
6-9
Schematic Diagrams
6-8 DVD M_Drive/RF
6-10
This Document can not be used without Samsung’s authorization
Samsung Electronics
Schematic Diagrams
6-9 DVD Audio_Dac
Samsung Electronics
This Document can not be used without Samsung’s authorization
6-11
Schematic Diagrams
6-10 DVD Input-Output
6-12
This Document can not be used without Samsung’s authorization
Samsung Electronics
SERVICE BULLETIN
ELECTRONICS
Product
:
COMBO
Bulletin No.
Model
:
Refer to the below
Bulletin Date :
Buyer
:
Refer to the below
ECN Date
SUBJECT :
MAIN PCB CHANGE INFORMATION
ECN No.
:
04-DVD-E0008
01-Jul-04
:
:
Background :
Note :
▶ Cause
- a short supply of RF IC from our supplier.
▶ Solution
- two Main PCBs use.
※ two Main PCBs are no problem with current DECK ASSY respectively.
but, make sure there are a difference of its Firmware due to different Main PCBs.
※ in order to ease to approach the unit, we marked "B" at the end of model name in a label rating on the rear.
ex) DVD-V4600/XAA-B
※ attached the pictures of two PCBs.
▶ Applicable models and buyers
- refer to the next page.
Application Date :
After 1st. July.
( Interchangeability Code : * I.C )
Location
OLD (before) Parts
NEW (changed) Parts
*
No.
SEC Code
Description
SEC Code
Description
I.C
801
AK92-00341A
ASSY PCB-MAIN DVD
AK92-00341E
ASSY PCB-MAIN DVD
A
Type
A type
E type
F type
Early OLD
Early OLD
Early OLD
Early
Parts Addition
Parts deletion
(Parts)
(Prod.) (Parts)
(Prod.) (Parts)
(Prod.) (Parts)
(Prod.)
(None → New)
( Old → Del. )
NEW
Late NEW
Late NEW
Late NEW
Interchange
OLD
Type Code
(* I.C )
B type
Application
Reference ( O )
Attachment
Schematic Diagram (
C type
Only Defected sets (
)
Mechanical Diagram (
Late
)
Whole sets (
Component Lay-out (
)
Product Month : About Dec. 13. 1999
Published by :
D type
None (
)
)
Exploded View (
)
Others ( ● )
)
Serial No. (~ from) :
Checked by :
Revision (V8.2 : March 10, 1998) ... Global Strategy Group. Tech.-Info. Suppot Part
Approved by :
J. S. PARK
( Pages :
1
of
1
)
APPLICABLE MODELs and BUYERs
DVD-V4300/GEN
DVD-V4600/XAA
DVD-V4300/GEN
DVD-V4600/XAA
DVD-V4300/RCL
DVD-V4600/XAC
DVD-V4300/RCL
DVD-V4600/XAC
DVD-V4300/STR
DVD-V4600/XAO
DVD-V4300/STR
DVD-V4600/XAO
DVD-V4300/XAO
DVD-V4600/XAP
DVD-V4300/XAO
DVD-V4600/XAP
DVD-V4300/XAP
DVD-V4600/XAX
DVD-V4300/XAP
DVD-V4600/XAX
DVD-V4300/XAX
DVD-V4600A/XAA
DVD-V4300/XAX
DVD-V4600A/XAA
DVD-V4500/XAA
DVD-V4650/RCL
DVD-V4500/XAA
DVD-V4650/RCL
DVD-V4500/XAC
DVD-V4650/XAX
DVD-V4500/XAC
DVD-V4650/XAX
DVD-V4600/GEN
DVD-V4700/XAA
DVD-V4600/GEN
DVD-V4700/XAA
DVD-V4600/RCL
DVD-V4700/XAC
DVD-V4600/RCL
DVD-V4700/XAC
DVD-V4600/STR
DVD-V9090/AFS
DVD-V4600/STR
DVD-V9090/AFS
Picture of each PCB
No mark PCB
"B" mark PCB
Different point