Download Samsung AW0700B Product specifications
Transcript
DB68_02476A(4)-AW0700B~ 2/18/03 4:14 PM Page 3 ROOM AIR CONDITIONER AW0700B AW07F0SAB AW07F(A)1SBA AW07F(A)2SBA AW07F(A)1SDA AW07F(A)2SDA AW07F(A)0SEA AW07F(A)1SEA AW07F(A)2SEA AW0800A AW08F0SAA SERVICE AIR CONDITIONER AW09F(A)1SBA AW09F(A)2SBA AW09F(A)2SBC AW09F(A)1SDA AW09F(A)2SDA AW09F(A)0SEA AW09F(A)1SEA AW09F(A)2SEA AW09F0SAA AW12F(A)0JCA AW12F(A)1JBA AW12F(A)2JB(C)A AW12F(A)1JDA AW12F(A)2JDA AW12F(A)1JEA AW12F(A)2JEA AW1000A AW10F0JAA AW12F1JAA AW1200A AW1210A AW12F0MAA AW1400A AW14F(A)1MB(C)A AW14F(A)2MBA AWT18F(A)1MDA AW18F(A)1MEA AW18F(A)2MEA AW1800A AW18F(A)2MBA AW2410C AWT24F(A)1MEA AW24F(A)0MCA AW24F(A)1MBA AW24F(A)1MBC AW24F(A)2MBB AW18F(A)1MEB AW18F1MBD AW18F2MBD Manual CONTENTS 1. Precautions 2. Product Specifications 3. Installation and Operating Instructions 4. Disassembly and Reassembly 5. Troubleshooting 6 6. Exploded Views and Parts List 7. Block Diagram 8. Wiring Diagram SAM0111 DB68-02476A(4)-1 2/18/03 4:16 PM Page 1-1 1. Precautions 1. Warning: Prior to repair, disconnect the power cord from the circuit breaker. 2. Use proper parts: Use only exact replacement parts. (Also, we recommend replacing parts rather than repairing them.) 3. Use the proper tools: Use the proper tools and test equipment, and know how to use equipment may cause problems laterintermittent contact, for example. 4. Power Cord: Prior to repair, check the power cord and replace it if necessary. Fig. 1-1 Avoid Dangerous Contact 5. Avoid using an extension cord, and avoid tapping into a power cord. This practice may result in malfunction or fire. 6. After completing repairs and reassembly, check the insulation resistance. Procedure: Prior to applying power, measure the resistance between the power cord and the ground terminal. The resistance must be greater than 30 megaohms. 7. Make sure that the grounds are adequate. Fig. 1-2 No Tapping and No Extension Cords 8. Make sure that the installation conditions are satisfactory. Relocate the unit if necessary. 9. Keep children away from the unit while it is being repaired. 10. Be sure to clean the unit and its surrounding area. Fig. 1-3 No Kids Nearby! Fig. 1-4 Clean the Unit Samsung Electronics 1-1 DB68-02476A(4)-1 2/18/03 4:16 PM Page 1-2 Notice : The symbol of model name Type A B C 1-2 Model Name AW0700B AW07F(A)2SDA AW08F0SAA AW09F(A)2SDA AW07F0SAB AW07F(A)0SEA AW09F(A)1SBA AW09F(A)0SEA AW07F(A)1SBA AW07F(A)1SEA AW09F(A)2SBA AW09F(A)1SEA AW07F(A)2SBA AW07F(A)2SEA AW09(F(A)2SBC AW09F(A)2SEA AW07F(A)1SDA AW0800A AW09F(A)1SDA AW09F0SAA AW12F(A)0JCA AW12F(A)1JDA AW12F(A)2JEA AW12F1JAA AW12F(A)1JBA AW12F(A)2JDA AW1000A AW12F(A)2JB(C)A AW12F(A)1JEA AW10F0JAA AW1200A AW1210A AW12F0MAA AW14F(A)1MB(C)A AW14F(A)2MBA AWT18F(A)1MDA AW18F(A)1MEA AW18F(A)2MEA AW1800A AW18F(A)2MBA AWT24F(A)1MEA AW24F(A)0MCA AW24F(A)1MBA AW24F(A)1MBC AW24F(A)2MBB AW18F(A)1MEB AW18F1MBD AW18F2MBD Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 2-1 2. Product Specifications 2-1 Table Item Type Unit of AW0700B AW0800A AW09F0SAA Measure AW07F0SAB AW08F0SAA - AW1000A AW1200A AW1010A AW12F1JAA AW1210A AW10F0JAA AW12F0MAA AW1400A Remarks WINDOW Dimension: mm 520 x 345 x 485 600 x 394 x 595 660 x 425 x 730 (Width x Height x Depth) Voltage Volt 115 Phase - SINGLE Frequency Hz 60 Operation Current A 6.8 7.4 9.1 9.2 12 11.7 12.0 Power Consumption W 715 815 1000 1020 1300 1275 1400 Refrigerant Type FREON R-22 g 350 380 420 485 610 580 700 BTU/h 7000 8000 9000 10000 12300 12500 1400 BTU/h.W 9.8 9.8 9 9.8 9.4 9.8 10.0 Net Weight kg 28 29 29 45 45 50 61 Condenser Row 2 x 17 3 x 17 2 x 19 3 x 19 Condenser Fan Type Evaporator Row Evaporator Fan Type Refrigerant Charge Capacity EER 2 x 15 Propeller Fan 2 x 14 2 x 14 2 x 15 Blower Fan Motor MODEL IC-9630SWD6C Compressor (Rotary) MODEL 44A072HW1EB 44A080HU1EB 44B092HW1EF 44B102HU1EF 44B124HU1EL 44B124HU1EL 44B135HX1EL Overload Protect - IC-9630SWD6E AFS095ZREA AFS100ZREB OSME-708SWC OSME-806SWC MRA98706-12008 MRA12083-12008 MRA12093-12007 MRA12109-12007 MRA98693-12008 MRA98693-12007 MRA98693-12007 Compressor Capacitor µF/VAC 25/370 35/370 45/400 40/370 45/370 45/370 50/370 µF/VAC 6/450 6/450 6/450 8/440 15/450 8/450 8/450 RPM 800/750/700 Fan Motor Capacitor Fan Speed Thermo Control Air Swing Samsung Electronics 910/810/750 920/820/770 920/850/780 800/750/700 950/850/750 - THERMOSTAT MODEL NO or M2CK59ZT79-H 2-1 DB68-02476A(4)-1 2/18/03 4:16 PM Page 2-2 Table (cont.) Item Type Dimension: (Width x Height x Depth) AW09F(A)1SBA AW12F(A)0JCA AW14F(A)1MB(C)A AW1800A AW09F(A)2SBA AW12F(A)1JBA AW14F(A)2MBA AW18F(A)2MBA AW09F(A)2SBC AW12F(A)2JB(C)A Unit of AW07F(A)1SBA Measure AW07F(A)2SBA 520 x 345 x 485 600 x 425 x 730 600 x 394 x 595 Voltage Volt 220 (230-208) Phase - SINGLE Hz 60 Frequency 4.7 Operation Current A 3.5 4.7 6 6.5 9.1 12.5 9.5 12.5 W 750 1000 12.1 11 4.5 Power Consumption AW2410C/XAA AW24F(A)1MBC WINDOW mm AW24F(A)0MCA AW24F(A)1MBA AW24F(A)2MBB 1290 1400 1860 2790 2000 2790 2700 2500 Refrigerant Type R-22 FREON 1320 420 Refrigerant Charge g 410 420 510 570 1090 1280 525 Capacity BTU/h 7000 9000 1140 1320 12000 14000 18000 24000 23700 24000 24000 20500 8.5 EER BTU/h.W 9.3 9 9.3 10 9.7 8.8 45 53 61 71 64 2 x 17 2 x 19 3 x 16 3 x 16 3 x 19 8.5 8.2 Net Weight kg Condenser Row Condenser Fan Type Evaporator Row Evaporator Fan Type 29 2 x 15 2 x 15 2 x 15 3 x 15 Propeller Fan 4 x 15 2 x 15 2 x 14 3 x 15 4 x 15 4 x 15 3 x 15 Blower AFS145ZUEA YSK160-6A Fan Motor MODEL IC-9630SWF6G IC-9630SWF6G AFS105ZUEA OSME-906SWC Compressor (Rotary) MODEL 44A072IW1EB 44B092IW1EF 44B124HU1EL 44B135IU1EL 48B175IV1EH EDB260211A 55A240IU2EN YSK160-6A AFS145ZUEA AFS145ZUEA EDB260211A 44B092IW1EF 48B220IV1EH 44B092IU1EF INTERNAL Overload Protect - MRA12043-12008 MRA12032-12008 MRA12008-12008 MRA12074-12007 MRA12107-12007 INTERNAL INTERNAL MRA12068-12007 30/450 Compressor Capacitor µF/VAC 25/370 20/370 30/450 30/450 35/450 30/450 40/450 40/450 Fan Motor Capacitor Fan Speed Thermo Control Air Swing 2-2 µF/VAC RPM 3/450 3/450 3.5/450 6/450 6/450 6/450 THERMOSTAT MODEL 6/450 910/780/690 910/780/690 900/840/780 950/850/750 1060/1010/970 1060/1010/970 1030/980/930 NO or M2LJ49ZV32 NO or M2LJ49ZU32 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 2-3 Table (cont.) Item Type Unit of AW07F(A)1SDA Measure AW07F(A)2SDA AW09F(A)1SDA AW09F(A)2SDA AW12F(A)1JDA AWT18F(A)1MDA AW12F(A)2JDA AW18F1MBD AW18F2MBD Remarks WINDOW - Dimension: mm x 425660 x 730 x 425 x 730 x 730 600 x 394 x 595 660 x 425660 520 x 345 x 485 (Width x Height x Depth) Voltage Volt Phase - 200-220 200-220 220 SINGLE 50 Frequency Hz Operation Current A 3.7 4.7 6.8 10.5 8.0 Power Consumption W 740 1000 1330 2050 1800 Refrigerant Type 60 R-22 FREON g 410 360 660 1480 1150 BTU/h 7000 9000 12000 18000 18000 BTU/h.W 9.5 9.0 9.0 8.8 10.0 Net Weight kg 28 29 45 71 61 Condenser Row 2 x 14 4 x 16 3 x 15 Condenser Fan Type Evaporator Row 3 x 15 3 x 16 Evaporator Fan Type AFS105AUEA OSME-1206SWC YSK160-6A 48A124MV1EL 48B180MT1EH 48D180IU1EQ Refrigerant Charge Capacity EER Fan Motor MODEL Compressor (Rotary) MODEL Overload Protect - 2 x 15 Propeller Fan 2 x 14 2 x 14 Blower IC-9430SWJ5A 44A070MW1EB 44B092MW1EF MST24AMN-12008 MRA12054-12008 MRA98706-12008 MRA12108-12007 MRA12046-12007 Compressor Capacitor µF/VAC 20/400 30/450 30/450 40/450 35/450 Fan Motor Capacitor µF/VAC 3/450 3/450 4/450 6/450 6/450 RPM 910/860/810 910/860/810 890/840/780 930/880/830 1000/910/850 M2LJ49ZU32 M2LJ49ZU39 Fan Speed Thermo Control Air Swing Samsung Electronics THERMOSTAT MODEL M2LJ49ZV32 2-3 DB68-02476A(4)-1 2/18/03 4:16 PM Page 2-4 Table (cont.) Item Type AW07F(A)0SEA Unit of AW07F(A)1SEA Measure AW07F(A)2SEA AW09F(A)0SEA AW09F(A)1SEA AW09F(A)2SEA AW12F(A)1JEA AW12F(A)2JEA - AW18F(A)1MEA AWT24F(A)1MEA AW18F(A)1MEB AW18F(A)2MEA WINDOW Dimension: mm 520 x 345 x 485 660 x 425 x 730 600 x 394 x 595 (Width x Height x Depth) Voltage Volt 220-240 Phase - SINGLE Frequency Hz 50 Operation Current A 3.5 4.5 5.8 9 14 9.0 Power Consumption W 750 1000 1330 2000 3000 1950 Refrigerant Type FREON R-22 g 410 390 660 1160 980 785 BTU/h 7000 9000 12000 18000 24000 18000 BTU/h.W 9.3 9.0 9.0 9.0 8.0 8.5 Net Weight kg 28 29 45 60 71 55 Condenser Row Condenser Fan Type Evaporator Row Evaporator Fan Type Refrigerant Charge Capacity EER Fan Motor MODEL - 3 x 19 Propeller Fan 2 x 14 2 x 14 3 x 15 Blower IC-9430SWJ5A Compressor (Rotary) MODEL 44A070JW1EB 44B092JW1EF Overload Protect 3 x 16 2 x 14 2 x 15 AFS105AUEA OSME-1404SAC OSME-1256SWC OSME-1404SAC 48A124JV1EL 48B180JV1EH AWG5532EXC 48B1180JV2EH MST24AMN-12008 MRA12056-12007 MRA12030-12008 MRA12016-12007 INTERNAL MRA12147-12007 Compressor Capacitor µF/VAC 25/450 30/450 30/450 40/450 45/450 35/450 µF/VAC 2.5/450 3/450 3.5/450 6/450 6/450 6/450 RPM 850/810/750 910/860/810 890/840/780 1060/1010/960 930/880/830 1030/980/1930 Fan Motor Capacitor Fan Speed Thermo Control Air Swing 2-4 MODEL THERMOSTAT NO or M2LJ49ZV32 M2LJ49ZU32 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 3-1 2-2 Dimensions 2-2-1 Main Unit (Unit : mm) D Side view Front view H H W Type W H D A 520 345 485 B 600 394 595 C 660 425 730 Samsung Electronics 2-5 DB68-02476A(4)-1 2/18/03 4:16 PM Page 3-2 MEMO 2-6 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 1 3. Installation and Operating Instructions 3-1 Installation 3-1-1 Selecting Area for Installation 1. Make sure that you install the unit in an area providing good ventilation. The air conditioner must not be blocked by any obstacle affecting the air flow near the air inlet and air outlet. 2. Make sure that you install the unit in an area that allow good air handling. The installation area must be able to endure vibration from the unit. 3. Make sure that you install the unit away from heat or vapor. 4. Make sure that you install the unit in an area which is cool and has adequate space. 5. Make sure that you install the unit in an area away from TVs, audio units, cordless phones, fluorescent lighting fixtures and other electrical appliances (obtain a clearance of at least one meter). 6. Make sure that you install the unit in an area which provides easy drainage for condensed water. 7. Make sure that you install the unit in an area not exposed to rain or direct sunlight. (Install a separate sunblind if exposed to direct sunlight.) 8. Make sure that you install the unit in an area allowing good air movement. Do not install it in a space that would cause noise amplification of noise. 9. Fix the unit firmly if mounted in a high place. Caution: Do not use the air conditioner in the following environments : greasy areas (including areas near machines), or marine areas. Contact your local dealer for advice. Samsung Electronics 3-1 DB68-02476A(4)-1 2/18/03 4:16 PM Page 2 3-2 Controls and Components AW0700B AW07F0SAB AW07F(A)0SEA AW0800A AW08F0SAA AW09F(A)0SEA AW09F0SAA AW07F(A)1SDA AW07F(A)1SEA AW09F(A)1SEA AW09F(A)1SDA AW12F(A)1JBA AW12F(A)1JDA AW12F(A)1JEA AW14F(A)1MB(C)A AW18F(A)1MDA AW07F(A)2SBA AW07F(A)2SDA AW07F(A)2SEA AW09F(A)2SBA AW09F(A)2SBC AW09F(A)2SEA AW12F(A)2JB(C)A AW12F(A)2JEA AW1000A AW10F0JAA AW1200A AW1400A AW1800A AW24F(A)0MCA AW18F(A)1MEA AWT24F(A)1MEA AW18F(A)1MEB AW24F(A)1MBC AW18F1MBD Operating mode selection dial Temperature control dial Operating mode selection dial Temperature control dial Air flow blade swing switch AW14F(A)2MBA AW18F(A)2MEA AW18F(A)2MBA AW24F(A)2MBB AW18F2MBD Timer control dial Fan speed switch Temperature control dial Air flow blade swing switch AW2410C Operation mode selection dial Swing switch 3-2 Thermostat control Energy Saver switch Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 3 Installation and Operating Instructions 3-2-1 THERMOSTAT OFF : When the room temperature is lowered by the air conditioner, the gas within the thermostat will contract and cause a break in the electric contact. The compressor will then stop. After the compressor stops, the room temperature will rise ON : As the room temperature increases to a selected level, the gas within the thermostat expands, causing electric contact, which provides the source of electric power to the compressor. The room temperature will fall and the cycle will repeat. Control Operation : By turning the control knob clockwise(toward higher numbers), the temperatures will be cooler. By turning the control knob counterclockwise (toward lower numbers), the temperature will be warmer. Level 1 : Cool air will be supplied above 30~35° Level 1 : Cool air will be ceased below 28~32.5° Level 10 : Cool air will be supplied above 17.4~20.4° Level 1 : Cool air will be ceased below 14.4~17.4° 3-2-2 Operation The fan selector switch offers high and low fan cooling control levels to assure maximum comfort. The two fan speeds allow you to economically circulate room air flow on days when intense cooling is not required. When combined with the thermostat(set to call for conditioned air), these controls cool, dehumidify, filter, and circulate room air, with the fan continuing to circulate air even when the compressor is turned off. 3-2-3 Timer control The timer enables the air conditioner to operate for a specified period of time, and then turns off automatically while the user is sleeping, shopping, etc.. To use this function, set the ti to the desired time, and the air conditioner will automatically shut itself off after running for the selected period ot timer. Utility bills can be reduced and comfortable temperatures maintained with the use of the timer. For continuous operation, set the timer control to “continue”. 3-2-4 Air swing switch • On ( ) : Automatic oscillation distributes the air flow throughout the room. (controls left the right and left blade-V.) • Off ( ) : Maintains a fixed direction of air flow, Set the Air switch to OFF at the instant the wave fins come to the desired position. Samsung Electronics 3-3 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4 Installation and Operating Instructions 3-2-5 Fan speed switch The fan speed switch offers high and low fan cooling control levels to assure maximum comfort. The two fan speeds allow you to economically circulate room air flow on days when intense cooling is not required. When combined with the thermostat(set to activate the air conditioner)hese controls cool, dehumidify, filter, and circulate room air, with the fan continuing to circulate air while the compressor is turned off. 3-2-6 Ventillation switch Use the ventillation switch to exhaust stale air. • Open position : The air inside the room circulates while the outdoor air is introduced inside. • Closed position : The air inside the room circulates while the outdoor air is not introduced inside. 3-2-7 Energy Saver switch The energy saver switch controls the fan. • ENERGY SAVER OFF : The fan runs all the time, while the compressor cycle on and off. • ENERGY SAVER ON : The fan and compressor cycle on and off together. This results in wider variations of room temperature and humidity. NOTE : 3-4 If only the fan operation is desired, set the energy saver switch to “OFF” The fan will not run with the switch setting combination at “FAN” of mode control and “ON” of energy saver switch. Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-1 4. Disassembly and Reassembly 4-1 Compressor Replacement Flow Chart Locate cause of defect Release refrigerant Disconnect electrical wiring from compressor Cut refrigerant lines from compressor Plug disconnected lines Replace compressor Solder discharge line Inspect electrical wiring for defects, and terminals for correct and secure connections Solder suction line Use nitrogen gas Perform soldering function Y Problem? Fill system with nitrogen gas N Check for leakage Corrective action Leakage? Y Check refrigerant oil level N Release nitrogen gas? Y Low oil level? N Evacuate system Add oil as necessary Recharge system Pinch and braze filling tube Samsung Electronics 4-1 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-2 4-2 Checking the oil Fill the transparent container with 10cc of oil, and then conduct the test. 4-2-1 Oil quality Oil Condition Condition of Refrigerant Cycle Color Odor Normal Straw Yellow No Odor Return with the system Over-heated Brown Color - Change the oil Compressor Damage Dark Brown Pungent oil Change the oil Remarks 4-2-2 Replacing and refilling the refrigerant oil 1. Change the compressor - DO NOT recharge the oil as the compressor itself is already charged. 2. Change the condenser .... add 50cc 3. Change the evaporator .... add 50cc 4. When the refrigerant is replaced .... add 30cc oil. 5. After vacuum is completed, the oil is filled through the high pressure side. 6. In the event of a refrigerant leak, generally it is not necessary to add oil. (Unless the oil has leaked significantly.) 4-2 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-3 4-3 Disassembly and Reassembly Procedure (Type “A”) Stop operating the air conditioner, and pull out the power cord before repair. No. Part name Procedures ! Ass'y Grill 1. Pull the panel front and remove the screw on the grille. Remarks *The type of front-panel depends on models. 2. Hold the lower part of grill with two hands while pressing down on both sides of the ower part of the cabinet, pull it forward by about 30, and the then lift it up for removal. COOL °C Hour FAN POW ER @ Ass'y Cabinet / MOD E 1. Remove the two screws both side cabinet. 2. Pull the front both side, and remove the unit from the cabinet. # Ass'y Control 1. Remove the blade V and arm blade. 2. Remove 2 screws, and earth wire screw. 3. Remove two lead wire assemblies. 4. Take out the control box forward. Samsung Electronics 4-3 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-4 Disassembly and Reassembly No. Part name Procedures $ Frame Up 1. Remove 6 screws on the Frame up and remove the Frame up and the reinf from case cond. % Case Cond & Propeller Fan 1. Remove two screws on the bottom side, and 4 screws on the case cond. Remarks 2. Pull up the case cond and seperate the cond case from the cond. 3. Remove the nut flange, and remove the propeller fan. 4-4 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-5 Disassembly and Reassembly No. Part name ^ Cond Casing & Blower & Motor Samsung Electronics Procedures Remarks 1. Remove the cond casing. 1. Move the motor & blower toward the evap, and lift up the motor & blower from the frame low. 4-5 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-6 Disassembly and Reassembly Procedure(cont.) (Type “B”) Stop operating the air conditioner, and pull out the power cord before repair. No. Part name ! Ass'y Grill Procedures Remarks 1. Pull the grille air inlet and remove the screw on the grille. *The type of front-panel depends on models. 2. Hold the lower part of the grill with two hands while pressing down on both sides of the lower part of the cabinet, pull it forward by about 30, and then lift it up for removal. COOL °C Hour FAN POW ER @ Ass'y Cabinet / MOD E 1. Remove the screws on both sides of the cabinet to disconnect the cabinet and frame. 2. Pull the handle on the front side of the bottom, and remove the unit from the cabinet. # Ass'y Control 1. Remove 6 screws, and earth wire screw. 2. Remove three lead wire assemblies. 3. Remove the blade V and arm blade. 4. Take out the control box forward. 4-6 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-7 Disassembly and Reassembly No. Part name $ Frame Up % Case Cond & Propeller Fan Procedures Remarks 1. Remove 10 screws on the Frame Up. 1. Remove two screws on the bottom side, and 5 screws on the case cond. 2. Remove the nut flange, and remove the propeller fan. Samsung Electronics 4-7 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-8 Disassembly and Reassembly No. Part name ^ Blower & Motor Procedures Remarks 1. Remove two screws on the clip motor, and remove the clip motor. 2. Move the motor & blower toward the evap, and lift up the motor & blower from the frame low. & 4-8 Cond Casing 1. Remove the cond casing Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-9 Disassembly and Reassembly Procedure(cont.) (Type “C”) Stop operating the air conditioner, and pull out the power cord before repair. No. Part name Procedures ! Ass'y Grill 1. Pull the panel front and remove the screw on the grille. Remarks *The type of front-panel depends on models. 2. Hold the lower part of grill with two hands while pressing down on both sides of the lower part of the cabinet, pull it forward by about 30, and the then lift it up for removal. COOL °C Hour FAN POW ER @ Ass'y Cabinet / MOD E 1. Remove the screws on both sides of the cabinet to disconnect the cabinet and frame. 2. Pull the handle on the front side of the bottom, and remove the unit from the cabinet. # Ass'y Control Samsung Electronics 1. Remove 10 screws, on the evap cover and earth wire screw. 4-9 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-10 Disassembly and Reassembly No. Part name Procedures Remarks 2. Remove 3 screws on the control box and 2 screws on cover partition. 3. Seperate the terminal cover of compressor and compressor lead wire, motor lead wire. 4. Take out the control box forward. $ Ass'y - Evaporator 1. Remove for screws on the left and right side of the evaporator. % Plate - Evap Casing 1. Lift up the evaporator, and remove the tray drain. 2. Remove two screws on the left side of the plate evap casing. 4-10 Samsung Electronics DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-11 Disassembly and Reassembly No. Part name Procedures ^ Blower 1. Loosen the nut-washer, and remove the blower. & Propeller Fan 1. Remove two screws on the bottom side, and 5 screws on the case cond. Remarks 2. Loosen the hexagon nut, and remove the fan. * Motor Supporter & Motor 1. Remove four hexagon nuts on the base pan and partition. 2. Move the motor - assembly toward the condenser, and lift up the motor assembly from the frame. 3. Remove four hexagon nuts on the supporter-motor. Samsung Electronics 4-11 DB68-02476A(4)-1 2/18/03 4:16 PM Page 4-12 MEMO 4-12 Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-1 5. Troubleshooting 5-1 Special Precautions 5-1-1 Check the voltage of the of power source. The input voltage shall be, Model Type Voltage AW1400A ✳✳✳✳✳✳✳ ✳✳✳✳✳✳✳A✳ 115V~, 60Hz ✳✳✳✳✳✳✳B✳ 220V~, 60Hz ✳✳✳✳✳✳✳C✳ AW1800A AW2410C 208-230V, 60Hz ✳✳✳✳✳✳✳D✳ ✳✳T✳✳✳✳✳D✳ 200-220V, 50Hz ✳✳✳✳✳✳✳E✳ ✳✳T✳✳✳✳✳E✳ 220-240V, 50Hz The air conditioner may not operate properly if the voltage is out of this range. 5-1-2 Check weak and fragile parts. 5-1-3 Check the connection of terminals. 5-1-4 When a malfunction occurs: No Trouble Checkpoints ! Compressor does not run. 1. Check the thermostat position. 2. Check the connection of the lead wire. 3. Check the over load protector. 4. Check the compressor. 5. Check the position of the select switch. 1. Setting temp is lower than room temp. 2. Disconnection of the lead wire. 3. O.L.P is faulty 4. Compressor is faulty @ Motor does not run. 1. Check the connection of the lead wire & switch. 2. Check the motor 3. Check whether the unit is deicing. 1. disconnection of the lead wire 2. switch is faulty. 3. motor is faulty. 4. The unit is operating on the deice mode. # Low cooling capacity 1. Check the refrigerant leakage. 2. Check the evaporator condition. (freezing, blocked with dusts, etc.) ❋ Difference of temp. exists between the suction side and the discharge side at least 12˚C. ❋ Standard condition Indoor : 27˚C outdoor : 35˚C 1. Caused by the pipe crack. 2. shortage of refrigerant. 3. clean the evaporator & air filter. $ Noise 1. Check vibration of the pipe. 2. Check the propeller fan and blower (not loose or broken). 3. Check bearing noise of the motor. 4. Check the compressor noise against. 1. pipes are contact with the other parts. 2. the hex. nut is loose 3. the parts are broken 4. motor is faulty 5. compressor is faulty that of other compressors. Samsung Electronics Possible cause 5-1 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-2 6. Exploded View and Parts List 30-4 30-1 30-7 6 32 1 2 2-2 2-1 3 2-3 31 4 34 7 30-3 30-8 30-6 30-10 30-2 8 11 30-5 30-9 16 5 35 12 9 17 14 19 10 30 20 21 18 23 22 24 27 15 13 33 26 29 25 28 6-1 Main unit (Type “A”) You can search for the updated part code number through the ITSELF. URL : http://itself.sec.samsung.co.kr 6-1 Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-3 Exploded View and Parts List ■ Part List (Type "A") Q’ty No 1 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 Description GRILLE- AIR INLET ASS'Y PANEL- FRONT FILTER-GUARD FILTER-GUARD PANEL-FRONT BLADE-H ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y FRAME-LOW BLADE-V LEVER-DAMPER BLOWER MOTOR FAN(SINGLE C-OIL) MOTOR FAN(DUAL C-OIL) MOTOR FAN(SINGLE C-OIL) FAN-PROPELLER ASS'Y CASE COND FRAME UPPER FRAME REINF CONDENSER CONDENSER CAP ASS'Y BASE ASS'Y BASE TUBE CAPILLARY TUBE CAPILLARY(S/S COMP) TUBE CAPILLARY ASS'Y TUBE SUCTION ASS'Y TUBE SUCTION ASS'Y TUBE SUCTION TUBE DISCHARGE TUBE DISCHARGE TUBE DISCHARGE COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR NUT-WASHER GROMMET-ISOLATOR COVER-TERMINAL NUT FLANGE OLP OLP (MATUSHITA COMP) OLP OLP ASS'Y CABINET ASS'Y CABINET SHUTTER ANGLE,UP SHUTTER LEFT SHUTTER RIGHT BRACKET INSTALL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL PANEL CONTROL KNOB THERMO ASS'Y ACCESSORY NUT FLANGE NUT FLANGE Code No. DB64-00104A DB92-00052A DB74-00005A DB74-00005C DB64-00167A DB66-00053A DB96-00045B DB96-00045C DB90-00002D DB66-00052B DB66-70030A DB67-50078A DB31-00073E DB31-00004P DB31-00073B DB67-50077A DB90-00013B DB90-00014G DB61-00027B DB75-00002A DB75-00002B DB63-10388A DB90-20212F DB90-20212B DB62-00372A DB96-00552A DB96-00046A DB96-00008B DB62-00370A DB96-10736A DB62-00150C DB62-00391A DB62-00152A 44A072HW1EB DB95-00113E 44A080HU1EB 44B092HW1EF DB60-30028A DB73-00070A DB63-10026A DB60-30018A DB47-20001V DB35-00012B DB47-20066B DB47-20066E DB90-00133L DB90-00133M DB64-00048B DB92-00113A DB92-00112A DB61-30219F DB93-00470C DB93-00492A DB93-00470B DB93-00470J DB64-00258D DB64-50138A DB97-30156C DB60-30020A DB60-30004A Specification HIPS ASS'Y HIPS HIPS (GREEN) HIPS PP OD7.0,2Rx14S OD7.0,2Rx14S ASS'Y HIPS,T3 HIPS ABS IC-9630SWD6C(6P) IC-9630SWD6E(5P) IC-9630SWD6E(6P) ABS PP ASS'Y PP,GRAY OD7.0, 2Rx15S OD7.0, 2Rx15S EPDM SGCC-M,SC94445T ID1.3xL800 ID1.42xL1200 ID1.42xL1100 SAMSUNG COMP MATUSHITA COMP SAMSUNG COMP MATUSHITA COMP 44A072HW1EB 2R11S3R126-6 44A080HU1EB 44B092HW1EF M8 RUBBER,BLK NORYL M5 MRA 98706-12008 MRA 98705 MRA 12083-12008 MRA 12093-12007 ASS'Y ASS'Y HIPS,T3 ASS'Y ASS'Y SGCC-A,T1.6,BLK ASS'Y(SINGLE) ASS'Y(DUAL) ASS'Y ASS'Y HIPS SC-93434R ASS'Y M6 M6,SM20C AW0700B AW07F0SAB AW0800A 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 2 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 2 1 1 2 1 1 1 AW08F0SAA AW09F0SAA 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 2 1 1 Q’ty No 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 Description ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL,LOW CASE CONTROL,UP CAPACITOR(C-OIL) CAPACITOR(C-OIL) CAPACITOR(C-OIL) CAPACITOR(C-OIL) CLIP CAPACITOR C-FILM C-FILM SELECTOR SWITCH SELECTOR SWITCH POWER CORD THERMOSTAT ARM-BLADE Samsung Electronics Code No. DB93-00470C DB93-00492A DB93-00470B DB93-00470J DB61-00417A DB61-00418A 2501-001226 2501-001228 2501-001230 2501-001216 DB65-10008B 2301-001449 2301-001367 3406-001045 DB34-90022E DB39-00343A DB47-20074A DB66-70031A Specification ASS'Y ASS'Y ASS'Y ASS'Y SGCC-M SGCC-M,T0.7 25uF,400V 35uF,400V 45uF,400V 25/5uF,370V SGCC-M,T0.8 6000nF,440V 6000nF,450V 240V,25A,6P 250V,6A,3P 125V,13A MOLD CAM,2P PS AW0700B/XAA AW0700B/SEA AW07F0SAB 1 1 1 1 1 1 1 1 1 - 1 1 1 1 1 1 1 1 - AW0800A AW08F0SAA AW09F0SAA 1 1 1 1 1 1 1 1 1 - 1 1 1 1 1 1 1 1 1 - 6-2 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-4 Exploded View and Parts List ■ Part List (Type "A") Q’ty No Description Code No. Specification AW07F(A)2SBA AW09F(A)2SBA AW09F(A)2SBC 1 1 2 2-1 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 31 32 33 34 35 6-3 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) FILTER-GUARD(MODEL:AW✳✳F✳✳✳) PANEL-FRONT BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) FILTER-GUARD(MODEL:AW✳✳A✳✳✳) PANEL-FRONT BLADE-H ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y FRAME-LOW BLADE-V LEVER-DAMPER BLOWER MOTOR FAN(SINGLE C-OIL) FAN-PROPELLER ASS'Y CASE COND FRAME UPPER FRAME REINF CONDENSER CONDENSER CAP ASS'Y BASE (NO DRAIN) ASS'Y BASE (DRAIN) TUBE CAPILLARY TUBE CAPILLARY ASS'Y TUBE SUCTION ASS'Y TUBE SUCTION TUBE DISCHARGE TUBE DISCHARGE TUBE DISCHARGE COMPRESSOR COMPRESSOR COMPRESSOR NUT-WASHER GROMMET-ISOLATOR COVER-TERMINAL NUT FLANGE OLP OLP ASS'Y CABINET SHUTTER ANGLE,UP SHUTTER LEFT SHUTTER RIGHT BRACKET INSTALL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL,LOW CASE CONTROL,UP CAPACITOR(C-OIL) CAPACITOR(C-OIL) CLIP CAPACITOR C-FILM TIMER SELECTOR SWITCH POWER CORD THERMOSTAT ARM-BLADE PANEL CONTROL KNOB THERMO KNOB SELECTOR ASS'Y ACCESSORY NUT FLANGE NUT FLANGE DB92-00046C DB64-10158A DB92-00052A DB74-00005C DB64-00167A DB66-00053A DB92-70096E DB63-30158C DB64-70093A DB66-30191A DB75-00001B DB96-00045B DB96-00045A DB90-00002D DB66-30211B DB66-70030A DB67-50078A DB31-00073D DB67-50077A DB90-00013B DB90-00014G DB61-00027B DB75-00011B DB75-00002B DB63-10388A DB90-20212F DB90-20212B DB96-00077A DB96-00046A DB96-00008B DB96-10736A DB62-00150C DB62-00152A DB62-00483A 44A072IW1EB 44B092IW1EF 44B092IU1EF DB60-30028A DB73-00070A DB63-10026A DB60-30018A DB47-20002J DB47-20002A DB90-00133M DB64-00048B DB92-00113A DB92-00112A DB61-30219F DB93-00694B DB93-00694C DB61-00417A DB61-00418A 2501-001226 2501-001225 DB65-10008B 2301-001369 DB45-10008A DB34-90022E DB39-00344A DB47-20074A DB66-70031A DB64-00269A DB64-50138A DB64-50138B DB97-30156C DB60-30020A DB60-30004A ASS'Y HIPS ASS'Y HIPS (GREEN) HIPS PP ASS'Y HIPS HIPS PP OD7.0,2Rx14S OD7.0,2Rx14S OD7.0,2Rx14S ASS'Y HIPS,T3 HIPS ABS IC-9630SWF6G ABS PP ASS'Y PP,GRAY OD7.0, 2Rx15S OD7.0, 2Rx15S EPDM SGCC-M,SC94445T ID1.3xL900 ID1.42xL1100 ASS'Y OD9.52 OD7.93 OD7.93 OD7.93 ASS'Y ASS'Y ASS'Y M8 RUBBER,BLK NORYL M5 MRA12043-12008 MRA12032-12008 ASS'Y HIPS,T3 ASS'Y ASS'Y SGCC-A,T1.6,BLK ASS'Y ASS'Y SGCC-M SGCC-M,T0.7 25uF,400V 20uF,400V SGCC-M,T0.8 3000nF,450V 12Hr 250V,6A,3P 250V,13A MOLD CAM,2P PS HIPS SC-93434R SC-93434R ASS'Y M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-5 Exploded View and Parts List ■ Part List (Type "A") Q’ty No Description Code No. Specification AW07F(A)1SDA AW07F(A)2SDA AW09F(A)1SDA 1 1 2 2-1 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 31 32 33 34 35 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) FILTER-GUARD(MODEL:AW✳✳F✳✳✳) PANEL-FRONT BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) FILTER-GUARD(MODEL:AW✳✳A✳✳✳) PANEL-FRONT BLADE-H ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y FRAME-LOW BLADE-V LEVER-DAMPER BLOWER MOTOR FAN FAN-PROPELLER ASS'Y CASE COND FRAME UPPER FRAME REINF CONDENSER CAP ASS'Y BASE (DRAIN) TUBE CAPILLARY TUBE CAPILLARY ASS'Y TUBE SUCTION ASS'Y TUBE SUCTION TUBE DISCHARGE TUBE DISCHARGE COMPRESSOR COMPRESSOR NUT-WASHER GROMMET-ISOLATOR COVER-TERMINAL NUT FLANGE OLP OLP ASS'Y CABINET SHUTTER ANGLE,UP SHUTTER LEFT SHUTTER RIGHT BRACKET INSTALL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL,LOW CASE CONTROL,UP CAPACITOR(C-OIL) CAPACITOR(C-OIL) CLIP CAPACITOR C-FILM TIMER SELECTOR SWITCH SELECTOR SWITCH SELECTOR SWITCH POWER CORD(3 ROUND POL) POWER CORD(UCP2) THERMOSTAT ARM-BLADE PANEL CONTROL PANEL CONTROL KNOB THERMO KNOB SELECTOR ASS'Y ACCESSORY NUT FLANGE NUT FLANGE Samsung Electronics DB92-00046C DB64-10158A DB92-00052A DB74-00005C DB64-00167A DB66-00053A DB92-70096E DB63-30158C DB64-70093A DB66-30191A DB75-00001A DB96-00045A DB90-00002D DB66-30211B DB66-70030A DB67-50078A DB31-00073C DB67-50077A DB90-00013B DB90-00014G DB61-00027B DB75-00002A DB63-10388A DB90-20212B DB96-00077A DB96-00106B DB96-00008B DB96-10736C DB62-00150C DB62-00152C 44A070MW1EB 44B092MW1EF DB60-30028A DB73-00070A DB63-10026A DB60-30018A DB47-20001X DB47-20057R DB90-00133M DB64-00048B DB92-00113A DB92-00112A DB61-30219F DB93-00687C DB93-00687B DB93-00694A DB61-00417A DB61-00418A 2501-001236 2501-001225 DB65-10008B 2301-001369 DB45-10008A 3406-001045 DB34-90022E DB34-90022A DB39-10089Q DB39-00348A DB47-20074A DB66-70031A DB64-00268A DB64-00269A DB64-50138A DB64-50138B DB97-30156C DB60-30020A DB60-30004A ASS'Y HIPS ASS'Y HIPS (GREEN) HIPS PP ASS'Y HIPS HIPS PP OD7.0,2Rx14S OD7.0,2Rx14S ASS'Y HIPS,T3 HIPS ABS IC-9630SWJ5A ABS PP ASS'Y PP,GRAY OD7.0, 2Rx15S EPDM ID1.3xL900 ID1.5xL1000 ASS'Y OD9.52 OD7.93 OD7.93 ASS'Y ASS'Y M8 RUBBER,BLK NORYL M5 MST24AMM-12008 MRA12054-12008 ASS'Y HIPS,T3 ASS'Y ASS'Y SGCC-A,T1.6,BLK ASS'Y ASS'Y ASS'Y SGCC-M SGCC-M,T0.7 30uF,450V 20uF,400V SGCC-M,T0.8 3000nF,450V 12Hr 240V,25A,6P 250V,6A,3P 250V,6A,2P 250V,10A 250V,10A MOLD CAM,2P PS HIPS HIPS SC-93434R SC-93434R ASS'Y M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 6-4 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-6 Exploded View and Parts List ■ Part List (Type "A") Q’ty No Description Code No. Specification AW07F(A)0SEA AW07F(A)1SEA AW07F(A)2SEA 1 1 2 2-1 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 31 32 33 34 35 6-5 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) FILTER-GUARD(MODEL:AW✳✳F✳✳✳) PANEL-FRONT BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) FILTER-GUARD(MODEL:AW✳✳A✳✳✳) PANEL-FRONT BLADE-H ASS'Y EVAPORATOR ASS'Y FRAME-LOW BLADE-V BLADE-V LEVER-DAMPER BLOWER MOTOR FAN FAN-PROPELLER ASS'Y CASE COND FRAME UPPER FRAME REINF CONDENSER CONDENSER (GREEN) CAP ASS'Y BASE (DRAIN) TUBE CAPILLARY ASS'Y TUBE SUCTION TUBE DISCHARGE COMPRESSOR NUT-WASHER GROMMET-ISOLATOR COVER-TERMINAL NUT FLANGE OLP ASS'Y CABINET SHUTTER ANGLE,UP SHUTTER LEFT SHUTTER RIGHT BRACKET INSTALL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL,LOW CASE CONTROL,UP CAPACITOR(C-OIL) CLIP CAPACITOR C-FILM TIMER SELECTOR SWITCH SELECTOR SWITCH SELECTOR SWITCH POWER CORD(3 ROUND POL) POWER CORD(UCP2) POWER CORD(BF3:HONG KONG) THERMOSTAT ARM-BLADE PANEL CONTROL PANEL CONTROL PANEL CONTROL KNOB THERMO KNOB SELECTOR ASS'Y ACCESSORY NUT FLANGE NUT FLANGE DB92-00046C DB64-10158A DB92-00052A DB74-00005C DB64-00167A DB66-00053A DB92-70096E DB63-30158C DB64-70093A DB66-30191A DB75-00001B DB90-00002D DB66-30211B DB66-30212B DB66-70030A DB67-50078A DB31-00073C DB67-50077A DB90-00013B DB90-00014G DB61-00027B DB75-00002A DB75-00002B DB63-10388A DB90-20212B DB96-00077A DB96-00008B DB62-00150C 44A070JW1EB DB60-30028A DB73-00070A DB63-10026A DB60-30018A DB47-20001Y DB90-00133M DB64-00048B DB92-00113A DB92-00112A DB61-30219F DB93-00470E DB93-00694H DB93-00694K DB93-00687F DB61-00417A DB61-00418A 2501-001226 DB65-10008B 2301-001370 DB45-10008A 3406-001045 DB34-90022E DB34-90022A DB39-10089Q DB39-00348A DB39-00455A DB47-20074A DB66-70031A DB64-00268A DB64-00258D DB64-00269A DB64-50138A DB64-50138B DB97-30156C DB60-30020A DB60-30004A ASS'Y HIPS ASS'Y HIPS (GREEN) HIPS PP ASS'Y HIPS HIPS PP OD7.0,2R*14S ASS'Y HIPS,T3 HIPS,T3 HIPS ABS IC-9630SWJ5A ABS PP ASS'Y PP,GRAY OD7.0, 2Rx15S OD7.0, 2Rx15S EPDM ID1.3xL900 ASS'Y OD7.93 ASSY M8 RUBBER,BLK NORYL M5 MST24AMN-12008 ASS'Y HIPS,T3 ASS'Y ASS'Y SGCC-A,T1.6,BLK ASS'Y ASS'Y ASS'Y ASS'Y SGCC-M SGCC-M,T0.7 25uF,400V SGCC-M,T0.8 2500nF,450V 12Hr 240V,25A,6P 250V,6A,3P 250V,6A,2P 250V,10A 250V,10A 250V,13A MOLD CAM,2P PS HIPS HIPS SC-93434R SC-93434R ASS'Y M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-7 Exploded View and Parts List ■ Part List (Type "A") Q’ty No Description Code No. Specification AW09F(A)0SEA AW09F(A)1SEA AW09F(A)2SEA 1 1 2 2-1 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 31 32 33 34 35 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) FILTER-GUARD(MODEL:AW✳✳F✳✳✳) PANEL-FRONT BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) FILTER-GUARD(MODEL:AW✳✳A✳✳✳) PANEL-FRONT BLADE-H ASS'Y EVAPORATOR ASS'Y FRAME-LOW BLADE-V BLADE-V LEVER-DAMPER BLOWER MOTOR FAN FAN-PROPELLER ASS'Y CASE COND FRAME UPPER FRAME REINF CONDENSER CONDENSER (GREEN) CAP ASS'Y BASE (DRAIN) TUBE CAPILLARY ASS'Y TUBE SUCTION TUBE DISCHARGE COMPRESSOR NUT-WASHER GROMMET-ISOLATOR COVER-TERMINAL NUT FLANGE OLP ASS'Y CABINET SHUTTER ANGLE,UP SHUTTER LEFT SHUTTER RIGHT BRACKET INSTALL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL,LOW CASE CONTROL,UP CAPACITOR(C-OIL) CLIP CAPACITOR C-FILM TIMER SELECTOR SWITCH SELECTOR SWITCH SELECTOR SWITCH POWER CORD(3 ROUND POL) POWER CORD(UCP2) POWER CORD(BF3:HONG KONG) THERMOSTAT ARM-BLADE PANEL CONTROL PANEL CONTROL PANEL CONTROL KNOB THERMO KNOB SELECTOR ASS'Y ACCESSORY NUT FLANGE NUT FLANGE Samsung Electronics DB92-00046C DB64-10158A DB92-00052A DB74-00005C DB64-00167A DB66-00053A DB92-70096E DB63-30158C DB64-70093A DB66-30191A DB96-00045A DB90-00002D DB66-30211B DB66-30212B DB66-70030A DB67-50078A DB31-00073C DB67-50077A DB90-00013B DB90-00014G DB61-00027B DB75-00002A DB75-00002B DB63-10388A DB90-20212B DB96-00077B DB96-10736B DB62-00150C 44B092JW1EF DB60-30028A DB73-00070A DB63-10026A DB60-30018A DB47-20002U DB90-00133M DB64-00048B DB92-00113A DB92-00112A DB61-30219F DB93-00470D DB93-00694J DB93-00694L DB93-00687A DB93-00687B DB61-00417A DB61-00418A 2501-001236 DB65-10008B 2301-001369 DB45-10008A 3406-001045 DB34-90022E DB34-90022A DB39-10089Q DB39-00348A DB39-00455A DB47-20074A DB66-70031A DB64-00268A DB64-00258D DB64-00269A DB64-50138A DB64-50138B DB97-30156C DB60-30020A DB60-30004A ASS'Y HIPS ASS'Y HIPS (GREEN) HIPS PP ASS'Y HIPS HIPS PP OD7.0,2Rx14S ASS'Y HIPS,T3 HIPS,T3 HIPS ABS IC-9630SWJ5A ABS PP ASS'Y PP,GRAY OD7.0, 2Rx15S OD7.0, 2Rx15S EPDM ID1.42xL900 ASS'Y OD7.93 ASS'Y M8 RUBBER,BLK NORYL M5 MRA12056-12007 ASS'Y HIPS,T3 ASS'Y ASS'Y SGCC-A,T1.6,BLK ASS'Y ASS'Y ASS'Y ASS'Y ASS'Y SGCC-M SGCC-M,T0.7 30uF,450V SGCC-M,T0.8 3000nF,450V 12Hr 240V,25A,6P 250V,6A,3P 250V,6A,2P 250V,10A 250V,10A 250V,13A MOLD CAM,2P PS HIPS HIPS HIPS SC-93434R SC-93434R ASS'Y M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 6-6 6-7 1 2-2 2 2-1 2-3 32 23 31 32 22 30-1 30-7 30-10 29 26 30-2 25 5 28 27 6 30-5 30-3 30-4 30-11 30-6 30-9 33 7 30-8 12 8 30 9 4 3 13 10 34 15 11 21 14 19 17 16 20 18 2/18/03 4:18 PM 35 24 DB68-02476A(4)-2 Page 5-8 Main unit (Type “B”) Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-9 Exploded View and Parts List ■ Part List (Type "B") Q’ty No Description Code No. Specification AW1000A 1 1 1 2 2-1 2-2 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 30-11 31 32 33 34 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) PANEL-FRONT FILTER-GUARD(MODEL:AW✳✳F✳✳✳) FILTER-GUARD(MODEL:AW✳✳F✳✳✳) BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) PANEL-FRONT FILTER-GUARD(MODEL:AW✳✳A✳✳✳) BLADE-H ASS'Y BASE (NO DRAIN) ASS'Y BASE ASS'Y CONDENSER ASS'Y CONDENSER(GREEN) ASS'Y EVAPORATOR ASS'Y FRAME LOWER ASS'Y FRAME LOWER BLOWER BLOWER CLIP MOTOR MOTOR FAN MOTOR FAN FAN-PROPELLER ASS'Y CASE COND ASS'Y FRAME UPPER ASS'Y FRAME UPPER TUBE CAPILLARY TUBE CAPILLARY TUBE SUCTION TUBE DISCHARGE NUT-WASHER GROMMET-ISOLATOR OLP OLP COVER-TERMINAL GASKET COMPRESSOR COMPRESSOR ASS'Y CABINET ASS'Y CABINET SHUTTER ANGLE UP SHUTTER LEFT SHUTTER RIGHT BLADE V-L BLADE V-R BLADE V LINK BLADE LEVER DAMPER ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL LOW CASE CONTROL UPPER C-OIL (COMP) C-OIL (COMP) CLIP CAPACITOR C-FILM C-FILM SELECTOR SWITCH TIMER SELECTOR SWITCH SELECTOR SWITCH POWER CORD POWER CORD THERMOSTAT ARM BLADE MOTOR SWING PANEL CONTROL PANEL CONTROL PANEL CONTROL KNOB THERMO KNOB SELECTOR NUT FLANGE NUT FLANGE Samsung Electronics DB92-00071A DB92-00059A DB64-10145A DB92-00072A DB64-00168A DB63-00073A DB63-00073B DB66-00049A DB92-10319G DB64-70080A DB63-30142C DB66-30169A DB90-20184L DB90-20184B DB96-00587A DB96-00587B DB96-40203C DB90-50133H DB90-50133A DB67-50078A DB67-50073A DB65-10101A DB31-00074A DB31-00074D DB67-50072A DB90-00142B DB90-50142E DB90-50142F DB96-00387A DB62-00550A DB96-00348B DB62-00327B DB60-30028A DB73-00070A DB35-00004Y DB47-20001M DB63-10026A DB63-20002A 44B102HU1EF 44B124IU1EL DB90-00364B DB90-00364A DB64-00048C DB92-00111A DB92-00110A DB66-00051A DB66-00050A DB66-30170A DB66-60028B DB66-70024A DB93-00686A DB93-00688F DB93-00693A DB61-00417A DB61-00420A 2501-001229 2501-001236 DB65-10008B 2301-001448 2301-001378 3406-001045 DB45-10008A DB34-90022E DB34-90022A DB39-00343B DB39-00344A DB47-20074A DB66-70022D DB31-00084B DB64-00260A DB64-00270A DB64-00271A DB64-50138A DB64-50138B DB60-30020A DB60-30004A ASS'Y ASS'Y HIPS ASS'Y HIPS HIPS HIPS (GREEN) PP ASS'Y HIPS HIPS PP ASS'Y ASS'Y 2x17, FP1.5,T3FIN 2x17, FP1.5,T3FIN 2x14, D FIN ASS'Y ASS'Y ABS ABS SECC-P AFS095ZREA AFS105ZUEA ABS ASS'Y ASS'Y ASS'Y ID1.2xL750 ID1.3xL1100 OD12.7 OD9.52 M8 RUBBER,BLK MRA12109-12007 MRA12008-12008 NORYL EPDM ASS'Y ASS'Y ASS'Y ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) HIPS HIPS PP HIPS HIPS ASS'Y ASS'Y ASS'Y SGCC-M,T0.7 SGCC-M,T0.7 40uF,400V 30uF,450V SGCC-M,T0.8 8uF,440V 3.5uF,450V 240V,25A,6P 12Hr 250V,6A,3P 250V,6A,2P 125V,15A 250V,13A MOLD CAM,2P PS M2LJ49ZV32 HIPS HIPS HIPS SC-93434R SC-93434R M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 AW10F0JAA AW12F(A)1JBA AW12F(A)2JBA 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 6-8 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-10 Exploded View and Parts List ■ Part List (Type "B") Q’ty No Description Code No. Specification AW12F(A)1JDA AW12F(A)1JEA AW12F(A)2JEA 1 1 2 2-1 2-2 2-3 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30-1 30-2 30-3 30-4 30-5 30-6 30-7 30-8 30-9 30-10 30-11 31 32 33 34 6-9 ASS'Y GRILLE (MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET (MODEL:AW✳✳A✳✳) ASS'Y PANEL- FRONT(MODEL:AW✳✳F✳✳✳) PANEL-FRONT FILTER-GUARD(MODEL:AW✳✳F✳✳✳) BLADE-H ASS'Y PANEL- FRONT(MODEL:AW✳✳A✳✳✳) PANEL-FRONT FILTER-GUARD(MODEL:AW✳✳A✳✳✳) BLADE-H ASS'Y BASE ASS'Y CONDENSER ASS'Y EVAPORATOR ASS'Y FRAME LOWER BLOWER CLIP MOTOR MOTOR FAN FAN-PROPELLER ASS'Y CASE COND ASS'Y FRAME UPPER TUBE CAPILLARY TUBE SUCTION TUBE DISCHARGE NUT-WASHER GROMMET-ISOLATOR OLP OLP COVER-TERMINAL GASKET COMPRESSOR COMPRESSOR ASS'Y CABINET SHUTTER ANGLE UP SHUTTER LEFT SHUTTER RIGHT BLADE V BLADE V,R LINK BLADE LEVER DAMPER ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL CASE CONTROL LOW CASE CONTROL UPPER C-OIL (COMP) CLIP CAPACITOR C-FILM C-FILM SELECTOR SWITCH TIMER SELECTOR SWITCH SELECTOR SWITCH POWER CORD(3 ROUND POLL) POWER CORD(HONG KONG) POWER CORD(UCP2) POWER CORD(AUSTRALIA) THERMOSTAT ARM BLADE MOTOR SWING PANEL CONTROL PANEL CONTROL KNOB THERMO KNOB SELECTOR NUT FLANGE NUT FLANGE DB92-00071A DB64-10145A DB92-00072A DB64-00168A DB63-00073B DB66-00049A DB92-10319G DB64-70080A DB63-30142C DB66-30169A DB90-20184A DB96-30279A DB96-40173B DB90-50133A DB67-50073A DB65-10101A DB31-00074C DB67-50072A DB90-00142A DB90-50142F DB62-31741A DB62-31742A DB62-31740A DB60-30028A DB73-00070A DB47-20001V DB47-20001Z DB63-10026A DB63-20002A 48A124MV1EL 48A124JV1EL DB90-00364A DB64-00048C DB92-00111A DB92-00110A DB66-30170A DB66-60028B DB66-70024A DB93-00688C DB93-00688A DB93-00688G DB93-00688A DB93-00693C DB93-00693D DB61-00417A DB61-00420A 2501-001236 DB65-10008B 2301-001379 2301-001378 3406-001045 DB45-10008A DB34-90022E DB34-90022A DB39-10089Q DB39-00455A DB39-00348A DB39-00346A DB47-20074A DB66-70022D DB31-00084B DB64-00270A DB64-00271A DB64-50138A DB64-50138B DB60-30020A DB60-30004A ASS'Y HIPS ASS'Y HIPS HIPS (GREEN) PP ASS'Y HIPS HIPS PP ASS'Y 2x14,WAVE 2x14, WAVE ASS'Y ABS SECC-P AFS105AUEA ABS ASS'Y ASS'Y ID1.7xL1200 OD12.7 OD9.52 M8 RUBBER,BLK MRA98706-12008 MRA12030-12008 NORYL EPDM ASS'Y ASS'Y ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) PP HIPS HIPS HIPS ASS'Y ASS'Y ASS'Y SGCC-M,T0.7 SGCC-M,T0.7 30uF,450V SGCC-M,T0.8 4uF,450V 3.5uF,450V 240V,25A,6P 12Hr 250V,6A,3P 250V,6A,2P BP3 BF3 UCP2 AP3 MOLD CAM,2P PS M2LJ49ZV32 HIPS HIPS SC-93434R SC-93434R M6 M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 Samsung Electronics 1 1-1 35 34 Samsung Electronics 31 31-8 31-9 31-7 32 31-14 31-3 31-4 31-2 31-1 1-3 3 31-5 33 8 5 6 9 10 14-1 13 15 24 17 2 14 12 22 23 18 19 20 21 16 25 26 28 2/18/03 4:18 PM 31-6 1-2 1-4 4 9-1 11 27 DB68-02476A(4)-2 Page 5-11 Main unit (Type “C”) 6-10 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-12 Exploded View and Parts List ■ Part List (Type "C") Q’ty No 1 Description ASS'Y GRILLE ASS'Y PANEL FRONT 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 1 ASS'Y PANEL FRONT(MODEL:AW✳✳A✳✳✳) ASS'Y PANEL FRONT(MODEL:AW✳✳A✳✳✳) 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 1 ASS'Y GRILLE(MODEL:AW✳✳F✳✳✳) ASS'Y PANEL FRONT(MODEL:AW✳✳F✳✳✳) 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 2 ASS'Y BASE ASS'Y BASE 3 TRAY DRAIN 4 ASS'Y EVAPORATOR ASS'Y EVAPORATOR 5 MOUNT MOTOR 6 MOTOR FAN MOTOR FAN MOTOR FAN 8 ASS'Y EVAP PLATE CASING 9 BLOWER 10 ASS'Y EVAP CASING 11 ASS'Y COVER EVAP 12 PARTITION 13 CASE COND 14 FAN-PROPELLER 14-1 NUT WASHER 15 ASS'Y CONDENSER ASS'Y CONDENSER ASS'Y CONDENSER 16 TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY 17 TUBE SUCTION 18 TUBE DISCHARGE TUBE DISCHARGE 19 NUT FLANGE 20 COVER-TERMINAL 21 OLP OLP 22 NUT-WASHER 23 GROMMET-ISOLATOR 24 COMPRESSOR COMPRESSOR COMPRESSOR 25 ASS'Y CABINET ASS'Y CABINET 26 SHUTTER ANGLE UP 27 SHUTTER LEFT 28 SHUTTER RIGHT 31 ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL 31-1 THERMOSTAT 31-2 SELECTOR SWITCH SELECTOR SWITCH TIMER 6-11 Code No. DB92-00066C DB92-00067A DB64-00178A DB63-00100A DB66-00120A DB64-00177A DB92-70101F DB92-70101D DB64-10163A DB63-30167C DB63-30167B DB66-30205A DB64-70102A DB92-00066B DB92-00067A DB64-00178A DB63-00100C DB66-00120A DB64-00177A DB90-00304A DB90-00304G DB63-40019A DB96-00654A DB96-01039B DB61-00440A DB31-00075A DB31-00075B DB31-00075J DB96-00026A DB67-00096A DB96-00868A DB90-40174A DB70-10679A DB61-00448A DB67-00047A DB60-30028A DB96-00664A DB96-00664B DB96-01037A DB62-00566A DB62-00596A DB96-01022A DB62-00563A DB62-00534B DB62-00813A DB60-30018A DB63-10026A DB47-20001U DB47-20057U DB60-30028A DB73-00070A 44B124HU1EL 44B135IU1EL 44B135HX1EL DB90-00311A DB90-00311B DB64-00048D DB92-00109A DB92-00108A DB93-00483C DB93-00776A DB93-00696B DB93-00483E DB47-20074A 3406-001045 3406-001046 DB45-10008A Specification ASS'Y ASS'Y HIPS HIPS PP HIPS ASS'Y ASS'Y HIPS HIPS HIPS(GREEN) PP HIPS ASS'Y ASS'Y HIPS HIPS PP HIPS ASS'Y ASS'Y FO-PS 2x15 2x15 SGCC-M OSME708SWC OSME806SWC OSME906SWC ASS'Y ABS ASS'Y ASS'Y SGCC-M PP ABS 2x19 2x19 2x19 ID1.3xL900x2 ID1.42xL1400x2 ID1.42xL1200x2 OD9.52 OD9.52 M5 NORYL MRA98693-12007 MRA12074-12007 M8 RUBBER,BLK ASS'Y ASS'Y ASS'Y ASS'Y ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) ASS'Y ASS'Y ASS'Y ASS'Y MOLD CAM,2P 240V,25A,6P 240V,25A,6P 12Hr AW1200A AW1210A AW14F(A)2MBA AW1400A 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 - Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-13 Exploded View and Parts List ■ Part List (Type "C") Q’ty No Description 31-3 CLIP CAPACITOR 31-4 C-OIL (COMP) C-OIL (COMP) 31-5 POWER CORD POWER CORD 31-6 PANEL CONTROL PANEL CONTROL PANEL CONTROL 31-7 CASE CONTROL UPPER 31-8 CASE CONTROL LOWER 31-9 SELECTOR SWITCH SWITCH TOGGLE SWITCH TOGGLE 32 LEVER DAMPER 33 ASS'Y FRAME BLADE ASS'Y FRAME BLADE 34 KNOB THERMO 35 KNOB SELECTOR Samsung Electronics Code No. DB65-10008B 2501-001230 2501-001231 DB39-00343B DB39-00344A DB64-00262C DB64-00264J DB64-00264D DB61-00418A DB61-00417A DB34-90022E 3401-001028 3401-001030 DB66-70024A DB90-00161A DB90-50161E DB64-50138A DB64-50138B Specification SGCC-M,T0.8 45uF,400V 50uF,370V 125V 250V,13A HIPS HIPS HIPS SGCC-M SGCC-M 250V,6A,3P HIPS ASS'Y ASS'Y SC-93434R SC-93434R AW1200A AW1210A AW14F(A)2MBA AW1400A 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 2 - 6-12 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-14 Exploded View and Parts List ■ Part List (Type "C") Q’ty No Description Code No. Specification AW1800A 1 ASS'Y GRILLE ASS'Y PANEL FRONT 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 1 ASS'Y PANEL FRONT(MODEL:AW✳✳A✳✳✳) ASS'Y PANEL FRONT 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 1 ASS'Y GRILLE(MODEL:AW✳✳F✳✳✳) ASS'Y PANEL FRONT(MODEL:AW✳✳F✳✳✳) 1-1 GRILLE AIR INLET 1-2 GUARD AIR FILTER 1-3 BLADE H 1-4 PANEL FRONT 2 ASS'Y BASE ASS'Y BASE 3 TRAY DRAIN 4 ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y EVAPORATOR 5 MOUNT MOTOR 6 MOTOR FAN MOTOR FAN MOTOR FAN 8 ASS'Y EVAP PLATE CASING ASS'Y EVAP PLATE CASING 9 BLOWER 10 CASE EVAP ASS'Y EVAP CASING ASS'Y EVAP CASING 11 ASS'Y COVER EVAP 12 PARTITION 13 CASE COND 14 FAN-PROPELLER 14-1 NUT WASHER 15 ASS'Y CONDENSER ASS'Y CONDENSER ASS'Y CONDENSER ASS'Y CONDENSER ASS'Y CONDENSER 16 TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY 17 TUBE SUCTION TUBE SUCTION TUBE SUCTION TUBE SUCTION 18 TUBE DISCHARGE TUBE DISCHARGE 19 NUT FLANGE 20 COVER-TERMINAL 21 OLP OLP OLP 22 NUT-WASHER 23 GROMMET-ISOLATOR GROMMET-ISOLATOR 24 COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR 6-13 DB92-00066C DB92-00067A DB64-00178A DB63-00100A DB66-00120A DB64-00177A DB92-70101D DB92-70101F DB64-10163A DB63-30167B DB63-30167C DB66-30205A DB64-70102A DB92-00066B DB92-00067A DB64-00178A DB63-00100C DB66-00120A DB64-00177A DB90-00304B DB90-00304E DB63-40019A DB96-00254A DB96-40207B DB96-01047A DB96-01038A DB61-00440A DB31-00075E DB31-00106A DB31-00075F DB96-00026A DB96-00026B DB67-00096A DB61-10182A DB96-00868A DB61-00609A DB90-40174A DB70-10679A DB61-00448A DB67-00047A DB60-30028A DB96-00328A DB96-00328B DB96-00092A DB96-01037A DB96-01048A DB62-00519A DB96-00283A DB62-00671A DB62-00518A DB62-00518C DB62-00673A DB62-01234A DB62-00457B DB62-00672A DB60-30018A DB63-10026A DB35-00004W DB35-00004X DB35-00011C DB60-30028A DB73-00070A DB73-00082A 48B175IV1EH 48B180MT1EH 55A240IU2EN 48D180IU1EQ ASS'Y ASS'Y HIPS HIPS PP HIPS ASS'Y ASS'Y HIPS HIPS(GREEN) HIPS(WHT) PP HIPS ASS'Y ASS'Y HIPS HIPS PP HIPS ASS'Y ASS'Y FO-PS 3x15 3x15 4x15 3x15 SGCC-M AFS145ZUEA YSK160-6A OSME1206SWC ASS'Y ASS'Y ABS FO-PS ASS'Y ASS'Y ASS'Y SGCC-M PP ABS 9.52-3x16 ID1.3xL1100x3 ID1.2xL1000x3 ID1.3xL1300x4 OD12.7 OD9.52 OD9.52 M5 NORYL MRA12107-12007 MRA12108-12007 MRA12046-12007 M8 RUBBER,BLK RUBBER,BLK ASS'Y ASS'Y ASS'Y ASS'Y 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 - AW2410C AW18F(A)2MBA AW18F1MBD AW18F2MBD AWT18F(A)1MDA 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 - Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-15 Exploded View and Parts List ■ Part List (Type "C") Q’ty No Description Code No. Specification AW1800A 25 26 27 28 31 31-1 31-2 31-3 31-4 31-5 31-6 31-7 31-8 31-9 32 33 34 35 ASS'Y CABINET ASS'Y CABINET SHUTTER ANGLE UP SHUTTER LEFT SHUTTER RIGHT ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL THERMOSTAT THERMOSTAT SELECTOR SWITCH SELECTOR SWITCH TIMER CLIP CAPACITOR C-OIL (COMP) C-OIL (COMP) C-OIL (COMP) POWER CORD(3 ROUND POLL) POWER CORD POWER CORD(PERPENDIC) PANEL CONTROL PANEL CONTROL PANEL CONTROL PANEL CONTROL CASE CONTROL UPPER CASE CONTROL LOWER SELECTOR SWITCH SELECTOR SWITCH SELECTOR TOGGLE SELECTOR TOGGLE LEVER DAMPER ASS'Y FRAME BLADE ASS'Y FRAME BLADE KNOB THERMO KNOB SELECTOR Samsung Electronics DB90-00311A DB90-00311B DB64-00048D DB92-00109A DB92-00108A DB93-00483A DB93-00696A DB93-00689A DB93-00669B DB93-00689T DB47-20074A DB47-20074E 3406-001045 3406-001046 DB45-10008A DB65-10008B 2501-001237 2501-001239 2501-001238 DB39-10089R DB39-00344A DB39-00200B DB64-00262C DB64-00263B DB64-00264D DB64-00264J DB61-00418A DB61-00417A DB34-90022E DB34-90022A 3401-001028 3401-001030 DB66-70024A DB90-00161A DB90-50161E DB64-50138A DB64-50138B ASS'Y ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) ASS'Y ASS'Y ASS'Y ASS'Y ASS'Y MOLD CAM,2P 240V,25A,6P 240V,25A,6P 12Hr SGCC-M,T0.8 35uF,450V 45uF,450V 40uF,450V 250V 250V,13A 250V,20A HIPS HIPS HIPS HIPS SGCC-M SGCC-M 250V,6A,3P 250V,6A,2P ON/OFF HIPS ASS'Y ASS'Y SC-93434R SC-93434R 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - AW2410C AW18F(A)2MBA AW18F1MBD AW18F2MBD AWT18F(A)1MDA 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 6-14 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-16 Exploded View and Parts List ■ Part List (Type "C") Q’ty No 1 1-1 1-2 1-3 1-4 1 1-1 1-2 1-3 1-4 2 3 4 5 6 8 9 10 11 12 13 14 14-1 15 16 17 18 19 20 21 22 23 24 25 26 27 28 31 31-1 31-2 31-3 31-4 31-5 31-6 31-7 31-8 31-9 32 33 34 35 6-15 Description ASS'Y PANEL FRONT(MODEL:AW✳✳A✳✳✳) GRILLE AIR INLET GUARD AIR FILTER BLADE H PANEL FRONT ASS'Y GRILLE(MODEL:AW✳✳F✳✳✳) ASS'Y PANEL FRONT(MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET GUARD AIR FILTER BLADE H PANEL FRONT ASS'Y BASE ASS'Y BASE TRAY DRAIN ASS'Y EVAPORATOR ASS'Y EVAPORATOR MOUNT MOTOR MOTOR FAN MOTOR FAN ASS'Y EVAP PLATE CASING BLOWER ASS'Y EVAP CASING ASS'Y EVAP CASING ASS'Y COVER EVAP PARTITION CASE COND CASE COND FAN-PROPELLER FAN-PROPELLER NUT WASHER ASS'Y CONDENSER ASS'Y CONDENSER(GREEN) ASS'Y CONDENSER TUBE CAPILLARY TUBE CAPILLARY TUBE SUCTION TUBE SUCTION TUBE DISCHARGE TUBE DISCHARGE NUT FLANGE COVER-TERMINAL OLP NUT-WASHER GROMMET-ISOLATOR COMPRESSOR COMPRESSOR ASS'Y CABINET SHUTTER ANGLE UP SHUTTER LEFT SHUTTER RIGHT ASS'Y CONTROL ASS'Y CONTROL(HONG KONG) ASS'Y CONTROL ASS'Y CONTROL(HONG KONG) ASS'Y CONTROL ASS'Y CONTROL(HONG KONG) THERMOSTAT SELECTOR SWITCH TIMER CLIP CAPACITOR C-OIL (COMP) C-OIL (COMP) POWER CORD(3 ROUND :HONG KONG) POWER CORD(NO PLUG) POWER CORD(UCP2) POWER CORD(AUSTRALIA) PANEL CONTROL PANEL CONTROL CASE CONTROL UPPER CASE CONTROL LOWER SELECTOR SWITCH SELECTOR SWITCH LEVER DAMPER ASS'Y FRAME BLADE KNOB THERMO KNOB SELECTOR Code No. DB92-70101D DB64-10163A DB63-30167B DB66-30205A DB64-70102A DB92-00066B DB92-00067A DB64-00178A DB63-00100C DB66-00120A DB64-00177A DB90-20215A DB90-00304E DB63-40019A DB96-00254A DB96-40207A DB61-00440A DB31-00075H DB31-00085A DB96-00026A DB67-00096A DB96-00025B DB96-00868A DB90-40174A DB70-10679A DB61-00448A DB61-10183A DB67-00047A DB67-50028A DB60-30028A DB96-00328A DB96-00328B DB96-30358A DB62-00519A DB62-31988A DB62-00518A DB62-31987B DB62-00067C DB62-00025A DB60-30018A DB63-10026A DB47-20001P DB60-30028A DB73-00070A 48B180JV1EH DB95-10351B DB90-00311B DB64-00048D DB92-00109A DB92-00108A DB93-00689E DB93-00696G DB93-00689C DB93-00713A DB93-00653A DB93-00714A DB47-20074A 3406-001045 DB45-10008A DB65-10008B 2501-001238 2501-001230 DB39-00349B DB39-10001K DB39-00348B DB39-00347A DB64-00263B DB64-00264D DB61-00418A DB61-00417A DB34-90022E DB34-90022A DB66-70024A DB90-50161E DB64-50138A DB64-50138B Specification ASS'Y HIPS HIPS(GREEN) PP HIPS ASS'Y ASS'Y HIPS HIPS PP HIPS ASS'Y ASS'Y FO-PS 3x15 3x15 SGCC-M OSME1404SAC OSME1256SWC ASS'Y ABS ASS'Y ASS'Y ASS'Y SGCC-M PP PP ABS ABS ID1.3xL1100x3 ID1.3xL800x3 OD9.52 OD9.52 M5 NORYL MRA12106-12007 M8 RUBBER,BLK ASS'Y AWG5532EXC ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) ASS'Y ASS'Y ASS'Y ASS'Y ASS'Y ASS'Y MOLD CAM,2P 240V,25A,6P 12Hr SGCC-M,T0.8 40uF,450V 45uF,400V 250V 250V,20A 250V,15A 250V,15A HIPS HIPS SGCC-M SGCC-M 250V,6A,3P 250V,6A,2P HIPS ASS'Y SC-93434R SC-93434R AW18F(A)1MEA AW18F(A)2MEA AWT24F(A)1MEA 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 INTERNAL 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-17 Exploded View and Parts List ■ Part List (Type "C") Q’ty No Description Code No. Specification AW24F(A)0MC(B)A AW24F(A)2MBB AW24F(A)1MBC AW18F(A)1MEB 1 1-1 1-2 1-3 1-4 1 1-1 1-2 1-3 1-4 2 3 4 5 6 8 9 10 11 12 13 14 14-1 15 16 17 18 19 20 21 22 23 24 25 26 27 28 31 ASS'Y PANEL FRONT(MODEL:AW✳✳A✳✳✳) GRILLE AIR INLET GUARD AIR FILTER BLADE H PANEL FRONT ASS'Y GRILLE(MODEL:AW✳✳F✳✳✳) ASS'Y GRILLE(MODEL:AW✳✳F✳✳✳) ASS'Y PANEL FRONT(MODEL:AW✳✳F✳✳✳) GRILLE AIR INLET GUARD AIR FILTER(GREEN) GUARD AIR FILTER BLADE H PANEL FRONT ASS'Y BASE ASS'Y BASE TRAY DRAIN ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y EVAPORATOR ASS'Y EVAPORATOR MOUNT MOTOR MOTOR FAN MOTOR FAN ASS'Y EVAP PLATE CASING ASS'Y EVAP PLATE CASING BLOWER CASE EVAP CASE EVAP ASS'Y COVER EVAP PARTITION CASE COND FAN-PROPELLER NUT WASHER ASS'Y CONDENSER ASS'Y CONDENSER(GREEN) ASS'Y CONDENSER ASS'Y CONDENSER TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE SUCTION TUBE SUCTION TUBE SUCTION TUBE SUCTION TUBE DISCHARGE TUBE DISCHARGE TUBE DISCHARGE NUT FLANGE COVER-TERMINAL COVER-TERMINAL OLP OLP NUT-WASHER GROMMET-ISOLATOR GROMMET-ISOLATOR GROMMET-ISOLATOR COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR ASS'Y CABINET ASS'Y CABINET SHUTTER ANGLE UP SHUTTER LEFT SHUTTER RIGHT ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL ASS'Y CONTROL Samsung Electronics DB92-70101D DB64-10163A DB63-30167B DB66-30205A DB64-70102A DB92-00066B DB92-00066C DB92-00067A DB64-00178A DB63-00100A DB63-00100C DB66-00120A DB64-00177A DB90-00304F DB90-00304E DB63-40019A DB96-00253A DB96-40207B DB96-01038A DB96-01047B DB61-00440A DB31-00075E DB31-00075H DB96-00026B DB96-00026A DB67-00096A DB61-10182A DB61-00609A DB90-40174A DB70-10679A DB61-00448A DB67-00047A DB60-30028A DB96-00328A DB96-00358B DB96-01037A DB96-01037B DB62-00516A DB62-00519A DB62-00588A DB62-00671A DB62-00515A DB62-00518C DB62-00518A DB62-00673A DB62-00514A DB62-00457B DB62-00672A DB60-30018A DB63-10026A DB63-00038A DB47-20002Z DB35-00011E DB60-30028A DB73-00070A DB73-00067A DB63-20003C 48B220IV1EH DB95-00113C 48B180JV2EH 55A240IU2EN DB90-00311B DB90-00311C DB64-00048D DB92-00109A DB92-00108A DB93-00483D DB93-00696C DB93-00689P DB93-00689S ASS'Y HIPS HIPS(GREEN) PP HIPS ASS'Y(GREEN FILTER) ASS'Y ASS'Y HIPS HIPS HIPS PP HIPS ASS'Y ASS'Y FO-PS 4x15 3x15 9.52-3x15 4x15 SGCC-M AFS145ZUEA OSME-140SAC ASS'Y ASS'Y ABS ASS'Y ASS'Y ASS'Y SGCC-M PP ABS 7.0-3x7 3x17 ID1.3xL1100x3 ID1.3xL1100x3 ID1.3xOD2.75xL900 ID1.3xOD2.75xL1300 OD15.88 OD9.52 OD9.52 OD9.52 M5 NORYL NORYL MRA12068-12007 MRA12147-12007 M8 RUBBER,BLK NR NR ASS'Y EDB260211A ASS'Y ASS'Y ASS'Y ASS'Y HIPS HIPS(ASS'Y) HIPS(ASS'Y) ASS'Y ASS'Y ASS'Y ASS'Y 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 INTERNAL 3 3 1 1 1 1 1 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 3 1 1 1 - 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 - 6-16 DB68-02476A(4)-2 2/18/03 4:18 PM Page 5-18 Exploded View and Parts List ■ Part List (Type "C") Q’ty No Description Code No. Specification AW24F(A)0MC(B)A AW24F(A)2MBB AW24F(A)1MBC AW18F(A)1MEB 31-1 31-2 31-3 31-4 31-5 31-6 31-7 31-8 31-9 32 33 34 35 6-17 THERMOSTAT SWITCH-ROTARY TIMER CLIP CAPACITOR C-OIL (COMP) C-OIL (COMP) C-OIL (COMP) POWER CORD POWER CORD POWER CORD PANEL CONTROL PANEL CONTROL PANEL CONTROL PANEL CONTROL CASE CONTROL UPPER CASE CONTROL LOWER SELECTOR SWITCH SELECTOR SWITCH SELECTOR SWITCH LEVER DAMPER ASS'Y FRAME BLADE ASS'Y FRAME BLADE KNOB THERMO KNOB SELECTOR DB47-20074A 3406-001045 DB45-10008A DB65-10008B 2501-001236 2501-001238 2501-001237 DB39-00200B DB39-00345A DB39-00347A DB64-00263C DB64-00264D DB64-00264B DB64-00263B DB61-00418A DB61-00417A DB34-90022E DB34-90022A DB34-90023A DB66-70024A DB90-50161E DB90-00161A DB64-50138A DB64-50138B MOLD CAM,2P 240V,25A,6P 12Hr SGCC-M,T0.8 30uF,450V 40uF,450V 35uF,450V 250V,20A 250V,15A 250V,15A HIPS HIPS HIPS HIPS SGCC-M SGCC-M 250V,6A,3P 250V,6A 250V,6A,2P HIPS ASS'Y ASS'Y SC-93434R SC-93434R 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 - 1 1 1 1 1 1 1 1 1 1 1 2 - Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-1 7. Block Diagram 7-1 Refrigerating Cycle Block Diagram PINCH PIPE (SERVICE VALVE) SUCTION LINE DISCHARGE LINE ACCUMULATOR/COMPRESSOR EVAPORATOR CONDENSER CAPILLARY TUBE PINCH PIPE (SERVICE VALVE) Samsung Electronics 7-1 DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-2 MEMO 7-2 Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-3 8. Wiring Diagram Samsung Electronics DIAGRAM-ELECTRIC AW1400A AW✳✳✳”0”✳✳✳ AW1800A DIAGRAM-ELECTRIC AW✳✳✳”1”✳✳✳ 8-1 DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-4 Wiring Diagram 8-2 DIAGRAM-ELECTRIC AW✳✳✳”2”✳✳✳ DIAGRAM-ELECTRIC AWT✳✳✳”1”✳✳✳ (OLP INTERNAL TYPE) Samsung Electronics DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-5 Wiring Diagram Samsung Electronics DIAGRAM-ELECTRIC AW✳✳✳”0”✳✳✳ (OLP INTERNAL TYPE) DIAGRAM-ELECTRIC AW2410C 8-3 DB68-02476A(4)-2 2/18/03 4:18 PM Page 8-6 UPDATE LOG SHEET Application date Page Part# Note(Cause & Solution) Use this page to keep any special servicing information. (Service Bulletin, etc.) If only parts number changes, Just change parts number directly on parts list. And if you need more information, please see the service website. Itself Solution Integrated technology supporting electronic library http://itself.sec.samsung.co.kr Copyright © 2002 By Samsung Electronics Co., Ltd. All rights reserved. This manual may not, in whole or in part, be copied, photocopied, reproduced, translated, or converted to any electronic or machine readable from without prior written permission of Samsung Electronics Co., Ltd. Printed in Korea. S/Bulletin# DB68_02476A(4)-AW0700B~ 2/18/03 4:14 PM Page 2 ELECTRONICS © Samsung Electronics Co., Ltd. Feb. 2003. Printed in Korea. Code No. DB68-02476A(4)