1
Download Tanaka TPE-270PN User's Manual
Transcript
Illustr ated P ar ts Man ual Illustra Par arts Manual Model Number: TPE-270PF/PN 26cc Portable Edger P/N 29249 Rev 001 Date 5-7-07 Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212 www.tanakapowerequipment.com [email protected] PARTS INFORMATION TPE-270PF/PN ENGINE / CYLINDER, PISTON, CRANKSHAFT • FIGURE 1 ITEM 1 2 3 6 7 9 11 12 13 14 16 17 18 40 41 46 47 50 55 PART NUMBER 157-01680-90 018-11610-21 255-01680-20 001-01680-90 994-61050-184 017-01680-200 041-01601-200 030-01680-90 039-00000-201 037-01700-200 046-01680-80 999-62091-325 068-10100-200 178-01680-80 274-01680-80 994-16040-186 182-0186A-201 167-21743-90 250-01680-20 DESCRIPTION CAP,SPARK PLUG ASS'Y PLUG,SPARK COVER,SPARK PLUG,RUBBER SET,CYLINDER BOLT,HEX,5X18,S GASKET,CYLINDER RING,PISTON SET,PISTON CIRCLIP,PISTON PIN PIN,PISTON CRANKSHAFT BEARING,NEEDLE,F-910 KEY,WOODRUFF,3X13X4.5 CORD,STOP CORD,EARTH SCREW,WS,4X18 WASHER,SPECIAL COIL,IGNITION ASS'Y TUBE,INSULATOR www.tanakapowerequipment.com Page 1 QTY 1 1 1 1 4 1 2 1 2 1 1 1 1 1 1 2 2 1 1 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN CRANKCASE, FLYWHEEL • FIGURE 2 P/N 046-01680-80 ITEM 19 19 19 19 21 22 26 31 32 33 34 36 37 38 51 52 54 PART NUMBER 330-00200-210 330-00200-220 330-00200-230 330-00200-240 991-01080-011 798-01630-200 359-10112-203 072-01680-90 999-66122-206 999-61600-100 090-01680-20 994-14050-251 990-11050-381 992-10050-012 155-21743-80 992-00080-011 991-01080-011 DESCRIPTION SHIM,12.2X19X.10 SHIM,12.2X19X.15 SHIM,12.2X19X.20 SHIM,12.2X19X.30 NUT,8 PULLEY,STARTER WASHER,CLUTCH B CRANKCASE,ASSY SEAL,OIL,#TC12227 BEARING,BALL,#6001 GASKET,CRANKCASE SCREW,5X25 SCREW,5X38 WASHER,S,5 ROTOR,MAGNETO WASHER,8 NUT,8 www.tanakapowerequipment.com QTY 1 1 1 1 1 1 1 1 2 2 1 2 2 2 1 1 1 Page 2 COMMENTS *Shims are "as needed" to obtain correct side clearance *Crankcase assy includes, bearings, seals and gaskets * Magneto includes starter pawls [email protected] PARTS INFORMATION TPE-270PF/PN FUEL TANK, FUEL SYSTEM, AIR CLEANER • FIGURE 3 P/N 455-01680-91 www.tanakapowerequipment.com Page 3 [email protected] PARTS INFORMATION TPE-270PF/PN FUEL TANK, FUEL SYSTEM, AIR CLEANER • FIGURE 3 ITEM 41 42 45 46 50 53 54 55 56 57 58 59 60 61 62 63 68 70 71 75 76 77 78 79 80 81 86 87 89 91 121 122 123 124 125 PART NUMBER 403-0097A-21 404-0097A-90 994-16050-241 402-0602K-21 455-01680-91 436-0162V-20 528-01680-20 999-67008-012 470-0602N-200 423-0637C-800 992-00050-011 992-10050-012 990-11050-602 446-0637C-200 452-01680-90 380-0637C-200 659-04300-20 442-25143-800 595-01680-90 649-01680-20 994-63050-204 940-04300-20 700-02504-080 534-32710-200 992-01050-061 994-61050-304 223-0162V-900 680-00731-201 675-04042-80 591-01685-20 564-00070-90 565-05032-20 646-3252L-90 680-00731-201 561-00070-20 DESCRIPTION GASKET,INLET MANIFOLD SET,CARB INSULATOR SCREW 5x24WS GASKET,CARBURETOR SET,CARBURETOR BASE,CLEANER VALVE,CHOKE O-RING,S-8 COLLAR,CLEANER BODY,CLEANER WASHER,SMALL,5 WASHER,S,5 SCREW,5X60 ELEMENT,CLEANER SET,CLEANER COVER BOLT,CLEANER COVER COLLAR C PUMP,PRIMING CAP,TANK ASS'Y COLLAR,TANK FIXING BOLT, HEX 5X20 STAND,ENGINE PIPE,FUEL,2.5X4X80 GROMMET,FUEL PIPE WASHER,5 BOLT,HEX,5X30S PIPE,FUEL,ASS'Y CLIP 6.3 FILTER,FUEL TANK VENT,AIR ASSY PIPE, AIR VENT AIR VENT VALVE ASSY CLIP 6.3 COVER,AIR VENT www.tanakapowerequipment.com QTY 1 1 2 1 1 1 1 1 1 1 2 2 2 1 1 1 3 1 1 1 2 1 2 1 1 1 1 1 1 1 1 1 1 1 1 Page 4 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN MUFFLER, CLUTCH, COVER • FIGURE 4 TPE-270PN TPE-270PF www.tanakapowerequipment.com Page 5 [email protected] PARTS INFORMATION TPE-270PF/PN MUFFLER, CLUTCH, COVER • FIGURE 4 ITEM 4-1 4-3 4-3 4-4 4-5 4-6 4-7 4-7 4-10 4-11 4-13 4-15 4-16 4-16 4-17 4-20 4-20 4-24 4-30 4-31 4-32 4-33 4-34 4-35 4-36 4-38 4-39 PART NUMBER 7380168120 7370168020 7370165A201 99415040182 99053060653 99201060011 7040168090 7040168790 7210440020 99434040081 7320440020 7360168022 1330168020 1330168720 7350168080 99413050081 99415050101 99415040142 2570168120 35902103200 29001620800 3420630B200 3480602R200 3570075T200 99416050162 99205080030 99072045164 DESCRIPTION PROTECTOR,MUFFLER GASKET,MUFFLER GASKET,MUFFLER SCREW,PS,4X18 SCREW,HEX,6X65 WASHER,6 SET,MUFFLER SET,MUFFLER PIPE,TAIL SCREW,4X8/S ARRESTER,SPARK COVER SHIELD,HEAT SHIELD,HEAT COVER,MUFFLER A SCREW,5X8 P SCREW,5X10/PS SCREW,4X14/PS COVER,SPARK PLUG WASHER,CLUTCH,B SHOE,CLUTCH SPRING,CLUTCH WASHER,CLUTCH A BOLT,STEP SCREW,5X16/WS WASHER,8 SCREW,TAPPING,4.5X16 www.tanakapowerequipment.com QTY 1 1 1 2 2 2 1 1 1 1 1 1 1 1 1 2 2 2 1 2 2 1 2 2 4 2 1 Page 6 COMMENTS TPE-270PF TPE-270PN TPE-270PF TPE-270PN TPE-270PF TPE-270PF TPE-270PN TPE-270PF TPE-270PF [email protected] TPE-270PF/PN PARTS INFORMATION RECOIL STARTER • FIGURE 5 ITEM 5-0 5-2 5-3 5-4 5-5 5-6 5-6 5-7 5-8 5-10 5-11 5-11 5-12 PART NUMBER 7620094090 78500940200 77200940801 78000940200 78300940200 77400940200 7740163021 7880163021 80105015200 8370501521 82205015200 8220423020 8390423020 DESCRIPTION STARTER,RECOIL ASS'Y HANDLE,STARTER BODY,STARTER SPRING,RECOIL ROPE,STARTER REEL,STARTER ROPE REEL,STARTER ROPE PAWL,STARTER WASHER,STARTER PULLEY PLATE,FRICTION SHIM,STARTER PULLEY SHIM,STARTER PULLEY BOLT,SET www.tanakapowerequipment.com QTY 1 2 1 1 1 1 1 1 1 1 1 1 1 COMMENTS Prior to S/N V218191 S/N V218191 and after Prior to S/N V218191 S/N V218191 and after Page 7 [email protected] PARTS INFORMATION TPE-270PF/PN CARBURETOR • FIGURE 6 0 www.tanakapowerequipment.com Page 8 [email protected] PARTS INFORMATION TPE-270PF/PN CARBURETOR • FIGURE 6 ITEM 0 1 4 5 7 10 11 12 13 16 17 18 19 20 21 22 23 24 41 PART NUMBER 4550168091 51425100200 54425164200 53925120200 48925100200 55025100200 5992001W38 ~ ~ ~ ~ ~ ~ ~ ~ ~ 5752514780 ~ ~ ~ ~ ~ ~ 47625004200 54825101200 61425137200 99101060013 4310634C200 5492516520 DESCRIPTION CARBURETOR SET SCREW,THROTTLE SET STAY,ADJUST,CABLE SWIVEL RING,STOP O-RING JET,MAIN LONG #38 *GASKET,PUMP *DIAPHRAGM,PUMP *SCREEN,INLET BODY,PUMP ASS'Y *GASKET,DIAPHRAGM *DIAPHRAGM,METERING COVER,DIAPHRAGM SCREW,SET ADJUSTER,CABLE NUT,6 GASKET,CLEANER WASHER,THRUST www.tanakapowerequipment.com QTY COMMENTS 1 Includes gasket 2 1 1 ~ Contained in Carburetor Repair Kit 1 P/N 650-25124-900 1 (Not available individually) 1 1 1 1 1 1 1 1 4 1 1 1 1 Page 9 [email protected] PARTS INFORMATION TPE-270PF/PN FAN CASE, CLUTCH DRUM • FIGURE 7 ITEM 1 5 6 8 11 15 20 26 27 28 PART NUMBER 289-0099E-80 599-00980-21 990-51050-163 994-61050-254 112-01680-80 360-00996-20 203-11660-200 992-01050-061 324-37350-20 361-00990-20 DESCRIPTION CLUTCH DRUM CUSHION,RUBBER BOLT,HEX,5X16 BOLT,HEX HOLE,5X25S CASE,FAN PIPE HOLDER,TPE GROMMET,PRIMARY CORD WASHER,5 WASHER,GEAR CASE FITTING,METAL www.tanakapowerequipment.com Page 10 QTY 1 1 1 1 1 1 1 1 1 1 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN THROTTLE LEVER, HANDLE, DRIVE SHAFT • FIGURE 8 www.tanakapowerequipment.com Page 11 [email protected] PARTS INFORMATION TPE-270PF/PN THROTTLE LEVER, HANDLE, DRIVE SHAFT • FIGURE 8 ITEM 1 2 3 4 5 9 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 47 49 PART NUMBER 353-37290-90 341-37290-20 344-37290-20 350-37290-20 320-37290-20 885-37394-80 500-33316-20 506-33316-200 990-23060-401 991-01060-011 992-01060-011 870-37286-90 162-37101-200 993-42030-081 259-37101-200 262-37101-200 177-37101-200 176-37101-200 315-33340-20 993-55060-001 832-37101-200 880-37101-200 994-31050-201 853-37101-200 958-37101-200 956-37101-200 260-33317-20 178-37394-80 164-10019-00 504-37300-200 DESCRIPTION SET,DRIVE SHAFT PIPE PIPE,DRIVE SHAFT SHAFT,FLEXIBLE LINER,FLEXIBLE SPACER WIRE,THROTTLE HANDLE BRACKET,HANDLE A BOLT,P,6X40 NUT,6 WASHER,6 LEVER,THROTTLE ASS'Y SWITCH,STOP SCREW, TAPPING, 3X8 BASE,STOP SWITCH SPRING,STOP SWITCH TERMINAL,EARTH B TERMINAL,EARTH A NUT,SPECIAL RING,STOP,6 SPRING,RETURN LEVER,THROTTLE SCREW,5X20 SHAFT,LOCK BUTTON SPRING,LOCK,BUTTON BUTTON,LOCK BODY,STOP BUTTON,B CORD,STOP 430mm TUBE,PROTECTION GRIP,SHAFT www.tanakapowerequipment.com Page 12 QTY 1 1 1 1 1 1 1 1 2 2 2 1 1 3 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN GEAR CASE, SAFETY GUARD • FIGURE 9 www.tanakapowerequipment.com Page 13 [email protected] PARTS INFORMATION TPE-270PF/PN GEAR CASE, SAFETY GUARD • FIGURE 9 ITEM 30 31 32 33 34 40 41 42 43 44 45 46 47 48 49 50 53 54 55 56 60 71 72 73 74 75 76 77 78 79 80 81 82 83 88 89 90 PART NUMBER 991-06080-001 992-01080-011 311-37290-20 435-37290-20 310-37290-22 300-37290-90 993-51032-002 999-61620-103 304-37290-20 999-61628-000 301-37290-00 994-23080-100 324-33410-201 300-37290-21 990-51050-103 994-61050-254 999-61609-000 999-61609-002 993-50009-002 993-51024-002 210-37290-80 992-10080-012 992-01080-011 120-37294-80 049-37294-20 441-37290-22 314-37294-20 481-37294-20 992-10060-062 990-53060-153 442-37290-21 445-37294-20 992-10060-062 990-53060-353 496-37290-20 500-37290-20 994-61050-124 DESCRIPTION NUT,8/L.H. WASHER,8 CAP,CUTTER HOLDER BLADE,TPE-250 HOLDER,CUTTER CASE,GEAR,ASSY RING,STOP,C-32 IN BEARING,BALL #6201D SHAFT,GEAR BEARING,BALL,#628 SET,GEAR/PINION BOLT,8X10 WASHER,GEAR CASE CASE,GEAR BOLT,HEX.HOLE,5X10 BOLT,HEX HOLE,5X25S BEARING,BALL,#609 BEARING,BALL,#609Z RING,STOP,C9 RING,STOP,C-28,IN HANDLE,LOCK WASHER,S,8 WASHER,8 WHEEL,TPE,6" COLLAR GUARD,BLADE TPE-2510 BOLT,SPECIAL STAY,WHEEL WASHER,S,6 BOLT,HEX,6X15 BRACKET,COVER HOLDER,BLADE GUARD WASHER,S,6 HEX, HOLE BOLT 6X35 HOLDER,MUD FLAP FLAP,MUD BOLT,HEX,5X12S www.tanakapowerequipment.com Page 14 QTY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 1 2 2 1 1 3 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN TOOLS • FIGURE 10 ITEM 1 2 7 PART NUMBER DESCRIPTION 829-20000-80 SPANNER,COMBI,13X19 813-20000-200 WRENCH,HEX,4 948-39907-200 BAG,TOOL www.tanakapowerequipment.com Page 15 QTY 1 1 1 COMMENTS [email protected] PARTS INFORMATION TPE-270PF/PN DECALS • FIGURE 11 ITEM 1 2 3 4 6 7 16 17 21 PART NUMBER 906-01680-20 906-47295-20 951-31310-200 923-33700-20 919-33111-201 929-38100-20 919-37286-20 920-32466-20 921-01681-20 DESCRIPTION PLATE,NAME,PUREFIRE PLATE,NAME,TPE-270PF DECAL,PRO-FORCE B DECAL,LEVEL DECAL,CAUTION DECAL,SYMBOL,PF DECAL,CAUTION DECAL,CAUTION DECAL,CAUTION www.tanakapowerequipment.com Page 16 QTY 1 1 1 2 1 1 1 1 1 COMMENTS [email protected]
