Download Craftsman 917.259170 Owner`s manual

J_
E
MODEL
£1
170
OWNER'S
MANUAL
o Assembty
_oOperation
_,_
Customer Responsibi!ities
o Service and Adjustments
_ Repsir Parts
CAUTION:
Read
and follow
FOR CONSUMER
aH safety
ASSISTANCE
rules
and instructions
before
operating
HOT LINE, CALL THiS TOLL FREE NUMBER:
this
1-800-659-5917
equipment,
SAFETY
Practices RULES
for Ride-On
Safe Operation
Mowers
IMPORTANT:
THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING
HANDS AND FEET AND THROWING
FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS
COULD RESULT IN SERIOUS INJURY
1.
o
o
o
o
o
o
_
,_
o
o
ill= CHILDREN
GENERAL
OPERATION
Read, understand, and fo_low al_ inst_cfions in the manuaI
and on the machine before starting.
Only allow responsible adults, who are familiar with the
instructions, to operate the machine.
Clear the area of objects such as rocks, toys, wire, etco,
which could be picked up and thrown by the blade.
Be sure the area is ctear of other people before mowing. Stop
machine if anyone enters the area.
Never carry passengers.
Do not mow in reverse unless absolutely necessary. Always
took down and behind before and while backing.
Be aware of the mower discharge direction and do not point
it at anyone_ Do not operate the mower without either the
entire grass catcher or the guard in ptace.
Slow down before turning.
Never leave a running machine unattended. Always turn off
blades, set parking brake, stop engine, and remove keys
before dismounting.
Turn off blades when not mowing.
Stop engine before removing grass catcher or unclogging
chute.
Mow only in daylight or good artificial light.
Do not operate the machine while under the influence of
alcohol or drugs.
Watch for traffic when operating near or crossing roadways.
Use extra care when loading or unioading the machine into
a traiier or truck.
Tragic accidents can occur if the operator is not alert to the
presence of chHdren. Children are often attracted to the
machine and the mowing activity.
Never assume that
children wil! remain where you tast saw them.
o
Keep children out of the mowing area and under the watchful
care of another responsible adu!t.
o
Be alert and turn machine off if children enter the area.
o
Before and when backing, look behind and down for small
children.
o
Never carry children. They may fail off and be seriously
injured or interfere with safe machine operation.
Never allow children to operate the machine_
o
Use extra care when approaching blind corners, shrubs,
trees, or other ob}ects that may obscure vision.
!Vo SERVICE
Use extra care in handting gasoline and other fuets= They are
flammable and vapors are explosive.
Use onIy an approved container.
Never remove gas cap or add fuei with the engine
running. Allow engine to cooi before refueling. Do not
smoke.
Never refuel the machine indoors.
Never store the machine or fuel container inside where
there is an open flame, such as a water heater.
Never run a machine nside a ciosed area.
Keep nuts and bolts, especiaily blade attachment bolts, tight
and keep equipment in good condition.
Never tamper with safety devices.
Check their proper
operation regularly.
Keep machine free of grass; leaves, or other debris build-up.
Clean oil or fuel spillage. Allow machine to cool before
storing.
Stop and inspect the equipment if you strike an object.
Repair, if necessary, before restarting.
Never make adjustments or repairs with the engine running.
Grass catcher components are subject to wear. damage, and
deterioration, which could expose moving parts or allow
objects to be thrown.
Frequently check components and
replace with manufacturer's recommended parts, when necessary.
Mower b{ades are sharp and can cut. Wrap the biade(s) or
wear gloves, and use extra caution when servicing them.
Check brake operation frequently. Adjust and service as
required.
_L SLOPE OPERATION
Slopes
tipover
death.
up the
OBJECTS.
OR DEATH_
are a maior factor related to loss-of-control and
accidents, which can result in severe injury or
AII slopes require extra caution. If you cannot back
siope or if you feel uneasy on it, do not mow it.
DO:
o
Mow up and down slopes, not across.
,_ Remove obstacles such as rocks, tree limbs, etc.
_
Watch for ho_es, ruts, or bumps.
Uneven terrain could
overturn the machine. Taft grass can hide obstacles.
o
Use slow speed. Choose a tow gear so that you will not have
to stop or shift while on the slope.
o
Follow the manufacturer's
recommendations
for wheel
weights or counterweights to improve stability.
Use extra care with grass catchers or other attachments.
These can change the stability of the machine.
Keep at! movement on the slopes slowand gradual Do not
make sudden changes in speed or direction.
o
Avoid starting or stopping on a slope. If tires lose traction,
disengage the blades and proceed slowly straight down the
slope.
Look for this symbol to point out important
safety
precautions,
It
means
CAUTION!!!
BECOME ALERT!!!
YOUR
SAFETY !S INVOLVED.
DO NOT:
Do not turn on slopes unless necessary, and then, turn slowly
and gradually downhill, if possible.
,_
Do not mow near drop-offs, ditches, or embankments. The
mower could suddenly turn over if a wheel is over the edge
o_ a cliff or ditch, or if an edge caves in.
o
Do not mow on wet grass. Reduced traction could cause
sliding.
o
Do not try to stabilize the machine by putting your foot on the
ground.
o
Do not use grass catcher on steep slopes.
CAUTION:
Always
disconnect
spark plug
spark plug in order to prevent accidental
wire
and place
where up,
it cannot
contact
starting
when wire
setting
transporting,
adjusting or making repairs.
A WARNING
The engine exhaust from this product contains
chemicals
known to the State of California
to
cause cancer, birth defects, or other reproductive harm.
2
CONGRATULATIONS
on your purchase of a Sears
Tractor. It has been designed, engineered and manufactured to give you the best possible dependability ad
Should you experience
any probiem
you cannot easiv
remedy,
please contact your nearest Sears Authorzed
Sewice CentedDepa_ment
Depa£mento
We have co,mpotent, wel-trained
technicians
and _h_ _,_o_r........
t_w-__:: _,_,
service or repair this tractor.
Piease read and retain this manuai.
The insirucdons
wiii
enabte you to assembie and maintain ,, ,,_*__*+'- ............
Always observe the .......
"" mt.)L£:©
PROBUOY
_ ORSEPOWER:
-_o _
,-__s.
UNLEADED
c.
OL "_'v
:_=_ ,API.SFfSG/SH'!:.
UO_
MODEL
NUMBER
917.259i
::: ",
SERIAL
;'iUMBERS
WiLL iE FO LIhd;L)
ON A PLATE UNDER THE SEAT.
YOU SHOULD RECORD BOTH SERIAL
DATE OF PURCHASE
AND KEEP
FOR FUTURE
REFERENCE.
AINTENANCE
o
0>
',
£';_',
_',,TA<:E:
:::&H;,:_grit
':ORWARLt):
{} -5.5
REiERSE:
1}-- 2.4
:] i- .:d:c:ACJ
1"G S" "_TE!', :
:'i
,_',; _"_::* R_I_T_'_s_V
.............
::: ,4 _,4S;C
s ova iaPie on this _/:_
ocustore for detaiso
RESPONSIBILITIES
WARNING:
This tractor is equipped with an internai
combustion engine and should not be used on or near any
unimproved forest-covered brush-covered or grass-cov o
004"--..006"
.007" -- 009"
:=: ,,-,_r_..
_iY]AF>'
"i0 ::>-c:,.,
=
::A_"
YEAR WARRANTY
SAE 30 (above A2°_c_.,
, ,
,._,= sW-ou (beiow 32"F)
......
7::2 ::: S!_SSURi%::
PLACE
Read and observe the safety rules.
Folowa reguJar schedule in maintaining, caring for and
using your tractor.
Follow the instructions
unclear C_;stomer
Responsibiiides" and =Storage" sections of this owners
manual.
LIMITED
< -': :ca="-,"-
R"
:.-/1:[_}
::.t,.i= '_Hk'--_
i ,3C,-':,:
AGREEMENT
A Sears Maintenance
Agreement
uct. Contact your earest
Sears
CUSTOMER
?,iUMBER !:;.isiD
!N A SAFE
REGuLAm
i
if:. CL:_L&RA?,C}-:
70
NUMBER
i THE MODELAND
SPECIFICATIONS
!:Ii_ADE :"= ...... "- "_ _="
]/)--I
¢::',k4s'_
30
240
Li.3 .
:_red and _sniesshe engine's exhaust system is equipped
wic_ e:ss__n_arrestor meeting aptsiicabie ioca or state Jaws
{it any.ls, f a spark arrestor is used, t shoutd be maintained
n effective wor}dn{}; order by the operatoro
:,:: the sta_e of Catfoma t_e above s _equired by law
:Sec_:o s 4442 of the Caifom a Pubfic Resources Code}.
Other states may save simi ar aws..::ederal _aws appiy on
fedora lands. A spark arresier for the muffbr is available
throu!_h your nearest Sears Authorized Sewice Cented
DepaEment (See REPAIR PARTS section of this manua }.
ON CRAFTSMAN
RIDING
EQUIPMENT
For two (2) years from the date of purchase, if this Cra_sman Riding Equipment is maintaineG iubricated and tuned up according
to the instructions in the owner°s manuai, Sears wiil repair or repiace, free of charge, any pars found to be defective in material or
workmanship.
TMs Warranty does not cover:
o
Expendabk items which become worn during normai use such ss b odes, spark plugs, air cleaners, beRs, etc.
o
Tire replacement or repair caused by punctures from outside obiects, such as naiJs, thorns, stumps, or giass.
o
Repairs necessary because of o_era_or abuse, neglgence improper storage or accident or the failure to maintain the
equipment according to the instructions contained in the owner*s manua.
Riding equipment used for commercial or rental purposes.
Lt fTED
90 DAY WARRAN
ON BAKERY
For ninety (90) days from date of purchase, if any batteq/ included with this riding equipment proves defective in material or
workmanship and our testing determines the battery wil not hold a charge, Sears will replace the battew at no charge.
IN-HOME WARRANTY SERVICE ON YOUR CRAFTSMAN RIDING EQUIPMENT IS AVAILABLE AT NO-CHARGE
FOR 30
DAYS FROM THE DATE OF PURCHASE. PLEASE CONTACT YOUR NEAREST SERVICE CENTER. AFTER 30 DAYS FROM
THE DATE OF PURCHASE, WARRANTY SERVICE IS AVAILABLE BY TAKING YOUR CRAFTSMAN RIDING EQUIPMENT TO
YOUR NEAREST SEARS SERVICE CENTER. (iN-HOME WARRANTY SERVICE WILL STILL BE AVAILABLE AFTER 30 DAYS
FROM THE DATE OF PURCHASE BUT A STANDARD TRIP CHARGE WILL APPLY.} THIS WARRANTY APPLIES ONLY
WHILE THIS PRODUCT IS IN THE UNITED STATES.
This Warranty gives you specific legal rights, and you may also have other rights which may vary. from state to state.
SEARS,
ROEBUCK
AND CO., D/817 WA, HOFFMAN
L,_. _A_ _S, IL 60179
TABLE OF CONTENTS
A
"-\C C!_S £ :7 1 :?* ...........................................
,,,d its
_.:,
5
" " ::
,
?©
Operation .....................................
i 1-14
E!ectr cak
O!}erating Mower. .....................
12_i 3
interiocks and Reiavs ................. 24
Options:
i:\ccesso
_n£ ...........................
({
Schemat c ..............................
,}0
S[)an_
AriesX:_r
.....................................
Wirng Diagram .............................
31
. _qT-T'a-_:_c_
.......................
2i
Ar Fiter ......................................
i8
P_-_rk_(_
Bake ................................
" 2
A_ Scrqen ..................................
P
-: "_ { ontroi Cabie ......
9;_
Coonq Fins, E_-:gine...................
9
:r_
,.
qb,-_
...............
18
9'rc,:_c Seeci ica_ion,s...........................
2'
C Change ...................................
!@
() Leve .................................
3.I_!
R
Preparation ...................................
3
Repair Pa_s
<.:8
Repai_ f%÷_:s ............................
4955
S
S a_ing ........................................
I3
Safsv Ruies ...................................
Storage .......................................
27
{Seat ..........................................
!
?:
....
_
g with
.............
.........
24
Ser,4ce and Adiustments ..............
20-26
S r_'_e ......................................
27
Brake .....................................
2;2
T<_rmnais....................................
17
Air ................................................
18
Ca_ureter .................................
Pqts:
Fue_...............................................
19
Fuse ......................................
1:£4
Fael:
Hood RemovaHnstaD£ion
...........
24: (__ovai/R_,<)acement
e2
Type .........................................
I3
Motion Drive Belt
Moser Biade Drive
S orage ......................................
27
Removal/Replacement
........... Z2
_ emovaL/Re@acement
?_>
:c_.,-e
...................................................
24
Mower B_ade Drive Beit
5iacse:
Removat/Repiacement
.......... ;2
....
_,per _,g ..................................
Gauge Wheels .....................................
8
Mower Adjustment:
Pep acemen ...............................
17
Front-to-Back ........................
2"
H
Brake J_.dus ment
22
Side.to-Side ............................
2!
Hood RemovaHnst Ilation ................. 24
C
Mower
Installation
.......................
20
L
Carb_ retor / diustment .......................
25
Mower Removal ...........................
20
Leveiing Mower Deck ........................ 21
'''P _'
"__'actor ................................
12
Tire Care .............................
8173
..ubricat
on Cha_ ................................
16
CLstome,_ SesDonsibitities. .........
...... o,_.._? "
Siope Guide Sheet .............................
56
b_
Spark Plugs....................................
19
Maintenance Schedu e ......................
!E
A" Fiter ...................................
8
Specifications ..................................
8
Mower:
,q Screen, Engine ..................
18
S_arting the Engine .......................
8-14
Ad ustment Front4o-Back ......... 21
8atiec, / .....................................
_7
Steering Wheef
_ _,o
Adiastment S de-to.-Side ............
21
3 :qnf? Fin?, Engine ..............
',_
Stopping the Tractor ..........................
12
Biade Sharpening ....................... 17
/.t_qeOil ...............................
i8
Storage ...............................................
27
Blade Replacement .................... t7
71FHter
................................
19
T
Cutting Height ............................. 12
ark
Plugs ............................
19
Thrott}e
Control
Cable
Adjustment ..... 25
installation ...................................
20
T r : 7,r:
Tires .........................................
8,i7Z13
Operation ................................ 1i-14
_des
.....................................
17
TroubleShoolingCha_ ...................
28-29
Removal .....................................
20
L _brication Chart ....................
!6
•. :_<<"v:
_Jabtenance
Schedu!e
Tire Care ........................
C_@ng
Hegnt
Mower
...........
I6
8,17,23
.......................
I2
TransaxleRepairPaMs .................
47-48
h4owingTips.......................................
14
Muffler................................................
19
W
Spark Arrester. ......................... 3,41
Mulcher P!ate .......................................
9
O
Oil:
Cold Weather Conditions ....... 13,18
Engine .........................................
18
Storage ................................. _..... 27
4
Warranty ......................................
3
Wiring Diagram ..................................
3i
Wiring Schematic ...............................
30
These accessones and attachments were availab!e through most Sears reta o_ tets and service cer ters when the tractor was purchased.
Most Sears stores can order these items for you when you provide the m_-se,_msmber of your tractor°
SPARK
Sears
PLUG
offers a wide variety of attachments
that fit you£ tractor.
Many of
a:e stee
m'ay be made in these a_achments, or some may no _o_get be aveiiab e,
accessories and a_achments
treat are avai_aS_e tos,'}/our wastor,,
Most of these attachments
attaching and detaching.
do not require addtionat
tfitchss o_"corwersio
AERATOR promotes deep root growth for a heathy iawn. Tapered 2.5° nct stee spikes mounted on I0o ncn d art eter discs
puncture hoies in soii at close _ntervals to iet me st _re soa£ ir_,
Steel weight tray for ncreased penetration
BAGGER _ets you collect
grass clippings and eaves for a
healthier, seater _ooking lawn, Two Permanex conta nets ho!d
30-gaibn piastic bags°
BU_PER protects front end of tractor from damage.
oeow with brief expianadons
t vot.)rheaei
kits hose
of how tnev can neip
Contact yo_,_rr'_earest'Sears
store for the
_sa_do are i_sdicatee end a_'e ces_ r'_edfor easy
:}._,OW BLAB_i rotsnow re _:ovaiany
4ncn
fgh_ 48oincn wide
/-::ece's
af_ _c;:::_wrer
angecefto
rght Raises lowers
wx_ sde eve. i_c dStSb e skids: re_iaceabie, reversible scraper
_-:a Use with e cr}a ns a_s@
wneei weights andJor rear drawbar
s,,f{_}e:
!
S_,aOWS%_BOWERhas 40o sch swath, Dnxr> ype auger handies
aowde% _ and wet/heavy snow. Mounts easiiy with simpie pin
_r ar !_ement D scharge chute adiusts torn tractor seat. 6_nch
d smeter spout discharges snow 10 to 50 feet. Lfi controited at
_-actor seat, Use with chains and wheei weghs and/or tea
_:_rawbar weight.}
SPRAYERS use 12ovoIt DC e_ectric motor that connects to the
t acto_ battep7 or other 12-vo[t source.
Includes booms for
automatic spr&ying and hand heid wand for spot spraying° Wand
has ao ustab[e spray pattern. For abptying herbicdes_ insecfi,,,
sides fungicides and iiqud fe_iizers,
SPREABER/SBEDERS
make seeding, fertilizing and weed kiiio
ing easy. Broadcast spreaders are aiso usefd _for granuiar dec
icers and sand
CARTS make hauiing easy. Vade_/ of sizes svai!abie, piLS
accessories sucR as side panel kits, too caddy, ca_ cover,
protective mat and do_Iy.
COR|NG AERATOR takes small plugs out of sol to a_tow moisture and nutrients to reach grass roots. 36-inch swath
24
hardened steel coting tps. 150 [b. capacity weight tray.
£ASY OIL DRAIN VALVE makes oil changes easier, faster.
FRONT NOSE ROLLER canters in front d mower deck to reduce
chances d °scaiping" on uneven terrain.
GANG H_TCH tets you taw 2 or 3 putFbehind attachments at once,
such as sweepers, dethatche_, aerators (not for use with rollers,
carts or other heavy attachments}.
GAUGE WHEELS on both sides of the mower deck _educe
chances of"_aiping" on uneven terrain. For mower decks not so
SWEEPERS let you coitect grass clippings and [eaves.
TELLER has 5 hp engine and 36qnch swath to prepare seed beds
cat rate and compost _arden residue. Tiller has its own buittoin
lift and depth contro_ system and does NOY require a sieeve hitch.
Fits any !awn, yard or garden tractor. Smpiy hook up to the tractor
drawbar and go!
Optional
accessories
conve_ _nit for
dethatching, aerating, hiIIingo.owithout tools.
TIRE CHAINS are heavy duty; ctoseiy spaced extraolarge cross
links give smooth ride, outstanding traction.
TRACTOR CAB has heavy duty viny_ fabric over tubuiar steei
frame, ABS plastic top; ciear plastic windshie{d offers 360 degree
visibi ity. Hinged metal doors with catch. Keeps operator warm
and dq/. Remove vinyl sides and windshields for use as sun
protector in summer. Optior_a_ accessories
include:
tinted/
tempered said safety giass windshieid with hand operated wiper;
12-vo_t amber caution light for mounting on cab top.
VACS for powerful collection of heavy grass clippings and leaves.
Optiona_ wand attachment to pick up debris in hard-to-reach
piaces. VACJCH_PPER includes a ch}pper_shredder.
WEIGHT BRACKET for drawbar for snow remova_ applications.
Uses (t} 55 lb. weight.
WHEEL WEIGHTS for rear wheels provide needed traction for
snow removai or dozing heavy materials,
_ULCH RAK_DETHATCHER
bosens son and flips thatch and
matted _eaves to lawn surface for easy pickup. Twenty spring the
teeth. Usefut to prepare bare areas for seeding. AvaitaMe for front
or rear mounting.
H_GH PERFORMANCE
REEL_ACT_ON
SPRING TtNE DETHATCHER covers 36qnch wide path and
tosses thatch into targe hopper. Mounts behind tractor.
MULCHING CLOSE-OUT PLATE KF, once instatfed Iets you
roach, discharge or bag c!ippings (bagger optional) without
changing blades. For models not equipped as 3qml Convertibie
mowers,
See "MOWER" in the Repair Parts section of this
manual.
RAMP TOPS AND FEET let you toad and unload tractor from a
pickup truck. Use with 2 x 8 or 2 x 10 lumber.
ROLLER for smoother lawn surface,
36qnch wide 18-inch
diameter water-tight drum holds up to 390 lbs. of weight. Rounded
edges prevent harm to turf. Adjustable scraper automatically
cleans drum.
5
E
Parts packed
separately
i_ ca;ton
ii
I
:i
Seat
/
/,
..... : L.....
'
/
i
(!) L,ockwasher
3/8
Steeripe
Nhee °
:i
:qbChe
/
/ia_e
_i I!;Y
.......................
/'}i:)
i
:iiii_
! i
i ...........................
1
00{
Manual
i:Sa_s Baq
(1) Hex Boit
112-!3 x 1
/"
Parts bag contents
not shown
/ _-.,
p)_ Shoulder
Bolts
.............
%_;'
"\
I_
'L
%_'
::
' (2} Lock
'm
_,:_Screws
Washers
size
(2} Washers 318
x 7/8 x I4 Gauge
//
2
}})
"_'
full
_::_a_,'_e
,, i
i
/i
,_...............
_........
#10 x 518
Steering Wheet
#I0
(2) Centerlock Nuts
...... >
{2} Keys
/ 2}3/16Washers
x 3/4
/ x t6 Gauge
(2) Weld
Nuts #t0
/
(
Wee
jbq
Botts 114-20 x 3/4
(2) Hex Nuts 114-20
'
;C££¢ :<,sYlStOn
/,,
i
Ssaft
!
O
(2) s'_,<_'ers 9i32 x 518 x t6 Gauge
............
._.
_
...... 2 Lock Washers
Stope Sheet
114
LJ
Your new tractor has been assembled at the factory with except on of ttose parts eft unassembted for shipping purposes
To ensure safe and proper operation of your tracto_ aI parts and hardware you assemb e must be t ghtened secure y. Use
the correct tools as necessanl to insure proper tightness_
TOOLS
REQURED
FOR ASSEMBLY
iNSERT
A socket wrench set will make assembly easier. Standard
wrench sizes are tistedo
_o HEX BOLT
(1} 9/16' wrench
(I} 3/4" Socket w£sr ve racnet
(2) 7/16" wrenches
PhiI/ips Screwd iver
(21 I/2" wrenches
_re #ressu
e _8_ F_
UtiIity ,knife
When right or eft hand is mentioned
:_s ma_._a, t
means when you are in the operat n{# _:_ositon {seate{s
behind the steering wheei}.
:::
-<_
318 LOCK WASHER
FLAT
.........................
:}
rvASHER
Y:AEZL
/
UNPACK
CARTON
AiIAPT:E_:_
SXTENSION
o
Remove a[[accessibieoose ;_a_cs
_/_::_s c_e_ons
rein ca_ton See page 6}.
_o Cut from ton to bo_om, aior_c; r_es os a.__...... co >ers
of carton, and iay paneis flat.
,_ L_he.K for any additionai ioose [_ans c_ canor',s and
remove.
5116 HEX BOLT
,/
//
IZ
BEFORE ROLLING TRACTOR OFF SKID
A_ACH
ASSEMBLE
STEERING
WHEEL
, :_/'+
LOWEIa
STEERING
SHA_"
(See 1i 9. l }
EXTENSION SHAFT AND BOOT
Slide e_ension shaft onto lower steeling shaft_ Align
mounting hobs in extension and iower shafts and
instal 5/16 hex bott and bcknuL Tighten secureiy.
F_PORTANT: TIGHTEN BOLT AND NUT SECURELY TO
18-22 FT. LBS TORQUE.
if
o
o
".:
i
""1
L: -
/
FIG=I
...... w ..e ,._,__{,,._q freewheefing position to
d.........L_
.:y_,_as_
_ +......
_!s,,s_s,o_-' _ iSee '%0 TRANSPORT' in
. ,_
se,.t_,x
_nL.manual!.
tractor backwards off skid
Place tabs of steering boot over tab slots in dash and
push down to secure.
Remove band ng holding discharge guard up against
tractor
INSTALL STEERING WHEEL
Position front wheets of the tractor so they are pointing
straight forward.
HOW TO SET UP YOUR TRACTOR
SIide steering wheel adapter onto steering shaft extension.
CONNECT
°
Position steering wheel so cross bars are honzonta
(left to dght) and stide inside boot and onto adapter
°
Assemble iarge flat washer, 3/8 lock washer, 3/8 hex
bolt and tighten securely.
o
Snap steering wheel insert into center of steering
wheel.
o
Remove
gHt,
protective
materials
from
tractor
hood
tion
section
TRACTOR
for
location
,;
of con-
Press lift lever plunger and raise attachment lift lever to
its highest position.
o
Release parking
pedal.
brake by depressing
be connected
from acciden-
Lift b_ooO_o raised position.
Open terminal access doors remove term[na_ protective caps and discard.
trois)
o
(See Fig. 2)
Positive terminal must
first to prevent sparking
tal grounding°
and
OFF SKID (See Opera°
and function
BAKERY
CAUTION: Do not sho_ batte_ terminals by alorving a rvrench or any other
obiect to contact both terminals at the
same tmeo Before connecting battery,
remove metal bracelets,
rvristrvatch
bands.., rings, etc.
IMPORTANT:
CHECK FOR AND REMOVE ANY STAPLES
iN SKID THAT MAY PUNCTURE TIRES WHERE TRACTOR
tS TQ ROLL OFF SKID.
TO ROLL
SHA_
clutch/brake
7
o
tf this battery is put into service after month and year
indicated on label (label located between terminals)
charge battery' for minimum of one hour at 6-10 amps.
o
First connect RED battery cable to positive (+) battery
terminal with hex bolt, flat washer, !ock washer and hex
nut as shown. Tighten securely.
o
_L**,_',grounding_ble to negative(o)batre;":,t_,::
mnatwithremaininghexbo_t,flatwasher!ock
was/,_ nd bexnut°Tightensecu_eiy.
Cost ,_erminai
accessdoo,_s.
Uset_-:_:"
_r;alaccessdoo_ fo_:
nsr:ec_onfo_-secupeconnections(to t_,ghten
hard_
_:Ot On
CHECKT_REPRESSURE
The tires on your tractor were over nfiated at tPe factoP/for
shipping purposes. Correct tire p_essure is impoRant fo:
best cutting pedormance.
o
CHECK
for corrosion.
_o
RS
_
es:?
_
Ju7_, >SFre{uired).
Reduce tire pressure to PSI shown
'°PROD ;C°r
SPECIF!CAT[ONS" on page 3 of ths marua
DECK LEVELNESS
For best cutting resuits, mower bot;si c;sLoxd be
ieveied. See "TO LEVEL MOW R HO_St'G*
Ser_4ce and Adiustments sec_ e<_cf _s :_ _>rL,:_
ba_et!/.
Re _:::sc char{_ing.
CHECK
LOC}<
WASHEF_
>£2X _,£#T
",
FLAT
WASHER
/
FOR
PROPER
_'°"_
See [_e t_gures that are s _o¢in icr
mower biade drive bets hc : :
secton of ths maRLS
',_:.[:V
CHECK
A:{tet
vDu
BRAKE
ieartt
eesc 't? "xot e< ;_:c
/sx ..................
:- ,_
i _3:'_(:t!2(
SYSTEM
ow
to operate
jou
:solo
::
that the brake _s prope_v adju
'
.......
_ed. See
_,AK[[
n
;'_ "':
_ht:_ Ser\qcE!
8qd
,_,,d[t S!_T"eN
f:
£0:
3E
°"L, ;D,;:
sec:tlOY
S'_
Ot
manual
ASSEB_BLE
GAUGE
DECK (See Fig. 4}
SEAT
(See Fig. 3)
AdiL:s
before tightening adjustment bolt.
o
Ro,_ :re cardboard pack ng on seat pan°
P_ce seat on seat pan and assemble shoulder boil
_
. :__:_
..........
_,_'_e
bo_t._
adiustment
;oos_{ y. Do not tighten.
iockwast_erand fiatwasher
._. !]::::, !an shoulder bo#t sec_Jr@y.
_
*
Lower seat into ope_ting position and sit on seal
Sde s_u{_tuntii a comfo£abIe position is reached which
sows you to press dutchibm.ke pedal sit the way
(,IOW
GAUGE WHEEL
MOUNTING
Get off seat wit_ out moving its adjusted position°
-
TO
The gauge wheels are designed to Keep the _-_owe_deo:
proper position when operating mower, Be sL_e they are
properly adjusted to ensure optimt m mower _}edorrnance,
o Assemble gauge whe@s wth t_actor os a Iat eve
sudace.
Adjust mower to desireQ cutting heigt;t (See TO AbJUST MOWER CU_H'4G HEIGHT" n tse Operator
section of this manuai}
_, With mower in desirers heght of cut posi os gauge
wheels should be assembled so they are slighdy off the
ground. Instatl gatJge whee n appro0date he!e wth
shoWder bolt, 3/8 washer, and 3/5-I6 ockn_t s_d
tighten securely.
._ Repeat for opposte sde nst_lin£ _su_Te wr_ee Lq
same adjustment hole.
F_G 2
_NSTALL
WHEELS
BRACKET
;:::_as,: seat and tighten adiustment bolt securely.
_ \
,.....
- :_}T::J-/:-_: .................
_,
",
SEAT
\,
SEAT PAN
::...
/.
,
3i_o,16
.....
_:<:--...... ;" { ;
LOCKNUT _
_;5_£. _ _}uJ}cIz/::: ".
LARGE
318"
WASHER
FLAT WASHER
/
_
GAUGE WHEEL _j"
: "d,'
/'
'_
F_G. 4
LOCK WASHER
F|G. 3
8
'
j
......
:
;' 1
pOL
BOLT
.DEr_
NSTALL MULCHER PLATE
(See Figs. 5 & 6}
o
©EFLECTOR
_H_ELD ......
.. -
Install two iatch hooks to mulcher plate using screw,
washer, lock washer, and wetd nut as shown
NOTE: Pre-assembie weld nut to latch hook by inseRing
weid nut from the top wth hook pointing down.
o Tighten hardware securely.
o
Raise and hold deflector shietd in upright position_
o
Place front of mutcher ptate over front of mower deck
opening and slide into ptace0 as shown..
o
Hook front latch into hoie on front of mower _Je_.
;;
Hook rear latch into hoie on bac_<of mower deci<
ca_.....
- .............
--.
*
7
,%.
-
_
_
guard from mower° Raise a_d hotd
guard when a_aching mulcher ptate
and allow it to rest on p_ate while in
TO CONV_R
_ TO BAGGING
OR
/:/5_':_/?_E _"L:i.' £:P_b_C_ AL:D _'JC'Y
Y\CU:O MEW
:"1_,4_5_5";,R WE WSH :_fi::ASSURE _B'/4T I/OU £ECE/VE
G_EST
_ANCEAN_3
S',,__4CTfON
F_d
?WtS QUALITY P£ODL/C7.
Simply remove muicher p_ate and store in a safe place.
Your mower is now ready for discharging or installation of
optiona_ grass catcher accessow.
PLEASE REWEW THz? _CLLOWING
NOTE: it is not necessary to change biades. The muicher
blades are designed for discharging and bagging also.
HOOK POINTS DOWN
WELD NUT FRO_ THE TOP..-- ...............
\,k! /
"\
V
Aft assembiy instructions have been completed.
v
No remaining ioose pars _ncarton.
,,"
Bat_:eryis properiy prepared and charged.
I houi at 6 emps).
,/
Seat is adjusted comfo_abty and tightened secureiy
/
inflated° (For shipping purposes,
the tires were over nflated at the factopy).
¢"
Be sure mower deck is properiy Jeveied side-to-side/
front-toorear for best cutiing resuits. (Tires must be
properly inflated for ieveiing).
/
Check mower and drive beits. Be su_-ethey are routed
properiy around pul!evs and inside ai_ beit keepers_
/
Check wiring. See that eft connections are stiil secure
and wires are properly camped.
/
Before driving tractor, be sure freewheel contro_ is in
drive position°
J
,,
LOCK
WASHER
SCREW
LATCH
/
HOOK
/
LOCK
WASHER
WASHER
WELD
NUT
WHILE LEARNING HOW TO USE YOUR TRACTOR, PAY
EXTRA A _-ENTION TO THE FOLLOWING IMPORTANT
ITEMS:
WASHER
MULCHER
PLATE
_
CHECKLIST:
7
Engine oil is at proper tevet.
_.-" Fuel tank is fiiied with fresh, dean, regular un!eaded
gasoline.
¢ Become familiar with all controls - their location and
function. Operate them before you start the engine.
SCREW
F_G. 5
9
/
Be sure brake system is in safe operating condition.
/
It is important to purge the transmission before operating your tractor for the first time. Follow proper starting
and transmission purging instructions (See'%Q START
ENGINE" and "PURGE TRANSMISSION" in the Operation section of this manual).
[!- ese
-, :",Doismay appear on your tractor or in literature sup[ iied with the prod ;ct. Learn and understand the_ _ ear ing
£ /:"i"TERY
CAUTION OR
._ARNING
REVERSE
,- _,_;
_,_,r-,
_-.......
L,.s _ o
: . i:.L
_::
L,K__
r'}
REVERSE
iqOWER HEtGH-f
NEUTRAL
DIFFERENTIAL
._O_K
H!GH
r.q'S 12Fi;
PARK!NG BRAKE
LOCKED
LOW
PARKING BRAKE
÷
ATTACHMENT
.4_U1_H DISENGAGED
i',AGW_/R_ IFT
_,L_,_ CH ENGAGED
HYDROSTATIC FREE WHEEL
(Hydro Models only)
9 _N(:x_:rl, KEEP HANDS AND FEET AWAY
t0
KNOW YOUR TRACTOR
READ THiS OWNER'S
MANUAL
AND SAFETY
RU_
BEFORE
OPERATING
YOUR
TRACTOR
Compare the illustrations with your tractor to faro iiarize yourseif wtP: the:,(>cations of varieus ::ontro;s and adiustments
this manual for future reference.
CHOKE
A_4METER
5W_TCH
.....
Save
LIGHT
SW_'TCH
_.,_,_-_
=
\
THBO_LE
\
C_'
\
.........
\
Li_ _
.......
___
--
.
_
t _E
_
PLUNGER
-
%
,_TTA_H [_IEN
CLUTCH/
PEDAL
BRAKE
_:_7_7
__!
£j
HEIGHT
..............
............
_. ._.._,_ ATTACHIk,IENT
,l_
FREEWHEEL
CONTROL
..... _'"
PARKING
_"'-_,_.
SPEED
s _PH
BRAKE
MOTION
CONTROL
LEVER
" "
2MPH
!MPH
J
F_,Go7
Our tractors conform to the safety standards of the American Nationat Standards Institute.
A_ACH_ENT
CLUTCH LEVER: Used to engage the
mower blades, or other attachments mounted to your
tractor.
MOTION CONTROL LEVER: Se!ects the speed and direction of the tractor.
A_ACH_ENT
L_ LEVER: Used to raise and lower the
mower deck or other a_achments mounted to your tractor,
L_GHT SW_TCH: Turns the headlights on and off,
THROTTLE
CONTROL:
Used to control engine speed.
L_
LEVER PLUNGER: Used to retease a_achment lift
iever when changing its position,
CLUTCH!BRAKE PEDAL: Used for declutching and braking the tractor and starting the engine,
PARKING BRAKE:
brake position.
Locks ciutchibrake
_GN_T_ONSW_TOH: Used for starting and stopping the
engine,
pedal into the
HEIGHT ADJUSTMENT
cutting height.
FREEWHEEL CONTROL: Disengages transmission for
pushing or slowly towing the tractor with the engine off.
CHOKE CONTROL:
KNOB: Used to adjust the mower
AM,_aETER: Indicates batter'/charging
(-).
Used when starting a cold engine.
11
(+) or discharging
in severe
eye damage.
Always
wear safe_
glasses
or eye shietds
TO USE YOUR TRACTOR
TO S_!T PARKING
BRAKE
L:
_.
sensing
by the
parking
TO USE THROWLE
position
:_od
par<lng _,; _:eieve; n E_qGAGED" position and
e : _.s:_!.Tess_ e frcm c utchibrake pedal Pedal shouid
;-:_
n BRi:_KZ p s_o__ iv!ake sure parking brake
,_.'i i'so
tracYor
operadng
CLUTCH
L_VE_
COHTRO
tDLC
,_-'-,i
_
%.
\
RANKING
_::.
"ENGAGED'*
/ POSITION
BRAKE
TO MOVE
-4p/." /,
FORWARD
- -.)i
,_UI£_
"T:
!%,
BAC_(.WAT_D
Release parking brake and c utchibra_:e pedai
Sbwlv move motion _- _" .........to desired
TO ADJUST
/_!5_AK _:
_E,;,GH7
4DJUST_4_F?T
\ "DISENGAGED
POSITION
_
[( N OE_
FIGo 8
STOPP
_.
Ti-e d rect on and speed s movemerx is con_roi[ed by ive
modon control tevet
_, Sta_ tractor with motor contro eve < neuTr i :'.:
o
;.}[_IVE
AND
i
t'p7
_OTION
CONTROL
LEVER
.....
o_,
{See !;:ig_ ::'
Always operate engine at u f-_rotte
Operating engine at ess_:a:'u
::o_
e2.ce
_ <::.
baden! charging rate.
_- h-jl throttte offers the Des: bmuiTnq rm_do ,,,er .::._;::::_
mance.
Use choke control whet, ever ye are ..........
>-'.......e -,-_..............
no
not use to star a wart?! _Rm
......
g ;" ::_
._ To engage choke co_u:x} ::>2 :.:ns:.'.::u:. ]i,:_, _
nee in to disengage,
_D1SENGAGED'
...
tractor
sect;re,
_£CH_E?_?
;;}
your
CA_ON:
Always stop tractor com_pletely, as described a#ove_ before ea,_
i_g the operator's posit[o_:
n:>e_t_p:,,
grass catcher, etco
(See Figo 8}
Vo2r trac or is equipped wth an operator presence
sw_tc:.
_Jhen engine is running, any attem0t
o c :,::c: 1o eave the seat without fist setting the
t ::re
: ,utoff÷ ......
,_ e[ane
,, £e>;'e sdutch, bta£e !::ec_ainto fui 'BRAKE"
while
NG (See F[go 8):
MOVVi;;ic; BLADES 0, yore :£_achmest cutc> ever o ....k-:;_:NGAGED posi_io::.
GROUb__, ©RIVEDep ess dutch/brake pedai ;nto full "BRAKE" pos tion.
_, Move motion control iever to neutral (N} position.
B,s£O ;;;:_£iT:
THE MOTiOnS CONTROL LEVER DOES
NOT F }£TURN TO NEUTRAL (N} POSITION WHEN THE
CLLTC} BRAKE PEDAL,S DEPRESSED.
ENG i1;°: ..
Mow:, :_rottJe control to siow (o_>) position.
i_,_OTZ: Failure to move throttte control to slow (_)
position and altowing engine to idte before stopping may
cause e_ g ne to "bac_ire'L
Tu__ ;gMtion key to 'OFF' position and remove key.
Aways remove key when eavi_g tractor to prevent
.;ha hoiized use.
,,
Neve_ use choke to stop engine.
_¢OTE: Lnder certain conditions when tractor is standing
[dte with tfe engine running, hot engine exhaust gases may
cause t _OWning" of grass. To e!mlnate this possibility,
always stop engine when stopping tractor on grass areas.
MOWER
CU_ING
HEIGHT
(See Fig. 8)
The cutting height is controlled by turning the height uJiust _
ment knob in desired direction.
o Turn knob cbckwise (fr_) to raise cutting heighL
o Turn knob counterclockwise (_--"0 to bwer cutting
The cutting height range is approx;mateiy 'i -':/2" i:o $. T_e
heights are measured from the ground to the biade tip with
the engine not running_ These heights are approx mate
and may vary dependin{7 upon soil condtions
_eignt of
grass and types of grass being mowed
The average lawn should be cut to approximately 2-i/2
inches during the coot season and to over 3 :scnes
during hot months. For heaithier and better iook[ng
lawns, mow often and atter rnoderate growth.
o For best cutting performance, grass over 6 inches in
height should be mowed twice. _4ake the first cut
relatively high; the second to desired hei{!nt.
TO OPERATE
MOWER
(See Fig. 9}
Your tractor is equipped with ar operator press;_ c÷ sensing
switch. Any attempt by the opera4o_ to leave the seat with
the engine running and the attach_re _tc _.xc_e_ _;_._ged
w{ii
shut off the engine.
o
Select desired height of cut.
Lower mower with attachment lift controt,
o Start mower blades by engaging attachment ck;tch
control.
_- TO STOP MOWER BLADES - disengage attachme_4
clutch control,
12
_{SOTE:
Top_otecthoodfromdamagewhentransporting
yourt_actor
onathickoratrailer,besurehoodisdosedand
securedtotractorUseanappropriate
meansofb/inghood
toifactor(rope_cord etc)o
A_ACHMENT
CLUTCH
"ENGAGED"
POSIT_ON
AT_ACH_EN'T
'.
GUARD
FiG. 9
TO OPERATE
:'
ON NmLLS
_
hills with siopes greater than 15 ° and
do not drive across any s_ope°
,_
Choose the s!owest speed before starting up or down
hilts
o
o
ADD GASOLINE
Avoid stopping or changing speed on hills.
If slowing is necessary_ move throttle control tever to
slower position..
;_
Ftl fuel tank. Use fresh_ c!ean, r_m,qar unleaded
f_asoiine with a m nimum of 87 octane. (Use of !ceded
gasoiine will increase carbon and lead oxide depos ts
and reduce valve iife). Do not mix oi_ with gasoline.
Purchase fuet in quantities that can be used within 30
days to assure fuet freshness.
!I_PORTANT: WHEN OPERATING tN TEMPERATURES
BELOW32°F(0°C), USE FRESH CLEAN WINTER GRADE
GASOLINE TO HELP NSURE GOOD COLD WEATHER
STARTING
WARNING:
indicates that atcohoi b_ended
fuels (called gasoho_ or using ethanol or methanol} can
attract moisture which ieads to separation and formation of
acids during storage
Acidic gas can damage the fuel
system of an engine whife in storage. To avoid engine
problems: the fuel system should be emptied before storage of 30 days or Ionger. Drain the gas tank, start the
engine and iet it run until the fuet fines and carburetor are
empty. Use fresh fue_ next season. See Storage lnstmc o
tions for additional information°
Never use engine or
carburetor cieaner products in the fuel tank or permanent
damage may occur.
tf stopping is absohstefy necessac7, push clutch/brake
pedal quickly to brake position and engage parking
brake.
o Move motion control lever to neutral (N) position.
IMPORTANT:
THE MOTION CONTROL LEVER DOES
NOT RETURN TO NEUTRAL (N) POSITION WHEN THE
CLUTCH/BRAKE PEDAL IS DEPRESSED.
o
To restart movement, sfowly release parking brake and
clutch/brake pedaI.
o
o
Slowly move motion control lever to slowest setting.
Make all turns slowly°
TO TRANSPORT
(See Fig. I0}
When pushing or towing your tractor, be sure to disengage
transmission by piecing freewheel control in freewheeling
position. Free wheel control is located at the rear drawbar
of tractor.
o
Raise attachment
ment lift control.
o
Pull freewheel control knob out and hold in position by
inserting retainer spring into forward hole of control rod.
o
Do not push or tow tractor at more than two (2) MPH.
To reengage transmission, reverse above procedure.
Theen ne _:your recto has :,ee_ shipped fmmthe
facto_sv already filed with summer weight oii.
Check e ir}e o with tractor o_ eve/!{_round
Remove o fi ca;},,dipst c',4and wipe ciean, reinse£ t_qe
d pstick and screw cap ti{#ht, wet for a few seconds
remove and read oii tore. if necessac!_ add oil until
FULLS mark on dipstick is reached. Do not oveffi!io
For cold weather operation you should change oil for
easier stading (See _OIL V_SCOSITY CHART _in the
(_<÷ m .....Respoqsibitities section of this manuaf).
o change engine oit, see the Customer Responsibifites sec_ on in this manua.
lift to highest position with attach-
13
TO S _ART ENGIN=
PURGE
TRANSMISSEON
(See Fig, 7}
When sta_ing the engine for the first time or if the
entre ins run out of fuel, it wi/take extra cranking time
to move fuel from the tank to the engine.
o Be sxre freewheel control is in the transmission
_,
_,
freewheel
whie
the engine
is t'_CAUTION: tever
Never"
eHgage
or disengage
hinge
St on seat in operating position, depress clutch/
brake pedal and set parking brake.
Pace motion controt lever in neutral (N} position.
.S,ve attachment ctutch to =DISENGAGED" posi-
To ensure proper operation and 2edormar_--_-: i:: "*c,:-mended that the transmission be p,.=q:xe,_
before op(-s:finy
tractor for the first time Th;s
..........
;_
trapped air inside the .........+_=
=.m,ssk,
i "-_,.
........
,,,m,,-<:,Q "e-,:- oped during shipping of your. -_aco__
IMPORTANT: SHOULD YOUR TRANSbiIB< ;O -_..
REMOVAL FOR SERVICE
";- r_
SHOULD BE PuR_::.,
r:"-:
.',.:'_'kt '
BEFORE OPERATING :HG -i,::_'.
*
_iacetractorsafeiy oq eve_su: ::c
"__ :<_-;c_
roec
_:,arkingbrake set
D sengage _,ransrniss e _
, .........
;r! freewheeing
iostiol
......
. J-:F:-L:......
this sect!on of manua ).
el.
thro_Sle contnsl to fast (@) position
P I choke controf out for acoid engine sta£ at°
_';pL
For a warm engine sta£ attempt the choke
c_ -sro may not be needed.
_,_ote:Li:fore staRi_
sad the warm _d c:oid star,q_sg
DDeed:. : }s beiow
r.:_: t key nto gt tion _nd turn kev ciockwise to
'SIR_T _ position and reiease ke)_ as soon as
rxxr, e sta_so Do not _n sta,,ter continuously for
":o :_1
than fifteen seconds per minute° if the engine
::Des not start after severa_ a_empts, puss che_e
co:_:t_o n, wait a few mnu_es atd tG_ again, if
_ r:? ne sdH does not sta£, puI the choke controt out
: A retry
_
s Tt]nnin[_ move tnro_.fe canto
....z..
/v'it_ motion control iever _r --_-v_
-::;c.:
-disengage clutch/brake :}ecs_
Move motion centre! _eve_ -_._7c_-w_:_:_
_c:_:::L:
hok_ for five (5) seconos _v0_._ ,,_-_
,(:}OSition
.....
And
_/ARM _.v_cA_HEN
_'- ....
ST__"_
R tlh_
,'_" (50 _'-_
, and above)
Whe"_ engine sta£s, slowly push choke centre! i
_t
the engine begins to run smoothly, if tt_e
engi;se sta£s to run rough y, pIi the choke control
o_Jtsghty for a few seconds and then continue to
pusi the control in slowly.
,
T_,.:::_.ttachments and ground drive can now be
_s_ i If the engine does not accept the toad, resta£
the engine and aitow it to warm up for one minute
COLD WI:iiATHER STARTING (50 ° F and below)
,
Whet engine sta_s slowly push choke control in
unti the engf_e begins to run smoothly. Continue to
p:ssh the choke control in small steps alowing the
e s_!ineto accent sinai changes in speed and Ioad,
unt the choke contro_ is fully n. If the engine stads
o u_ roughly, pu! the choke contro_ out siightiy for
_:, few s_onds
and then continue to push the
corot_:ciin siow_y. This may require a_ engine warm°
up period from severat seconds to several minutes,
d_pending on the temperature.
HYDROSTATIC TRANSMISSION WARM UP
_, Before drk4ng the unit in cold weather, the transmssios should be warmed up as foIows:
o Be sure the tractor is on tevet ground.
', _qace the mot!on controi lever in neutral. R e:xr<se the parking brake and bt the clutch/
bake
slowly return to operating position.
"_ AIIow one minute for transmission to warm up.
ibs can be done during the engine warm up
period.
-, The:, _L.!tachments can be used during the engine
warm-up period after the transmission has been
warmed up and may require the choke control be
ptAed out slightly.
NOTE: If at a high altitude (above 3000 feet) or in cotd
temperatures (below 32 F) the carburetor fuet mixture
may need to be adjusted for best engine performance.
See "TO ADJUST CARBURETOR" in the Sep,Ace and
Adjustments section of this manual.
NOTI'.
fsoId for
,,_= _x
During this procedure
trite
seso[tQ:5
itlti
-,cOSeC
1)(-! _111_
moven-!d
'"
nY o]
drive wheels. The air is heine removed from h ;afoul,c"
," a,-_e-:
Move mot!on control _everto neuYral 'r__;:}oh x:en :-s off engine and set oarking r_ra_<e,
Engage transmisgion by placing _reewnee_ torture L_'s
driving position (See '_TOTRANSPORT" in ths sscst _
of manual),
S[Hing in the trac_or seat, start engine. After _ne enM_e
is running, move throttle control to bah {1/2} speec.
With motion control lever in neutral (N) position, siev. _y
disengage clutch/brake pedal
Slowly move motion control iever forward, a_er t¢:e
tractor moves approximately five (5) feet. stow_y move
motion controt lever to reverse _.,..._,....
tractor moves approximately five (5) fee_ [e_um the
motion control lever to the neutral (N) pesitktr. Repeat
this procedure with the motion cent_ol over thr_;e (3)
times.
Your tractor is now purged and sow ready for nomq_.}_
operation.
t4
_4ULOHING
Tire chains cannot be used when the mower housing is
attached to tractor.
o
o
o
o
Mower should be properly teveied for best mowing
performance. See '%0 LEVEL MOWER HOUSING" in
the Sewice and Adiustments section of this manua.
The left hand side of mower should be used for t:im_
Drive so that clippings are discharged onto the area
that has been cut. Have the cut area to the right of the
tractor. This wNl result in a more even distribut on of
ciippings and more uniform cuttmg..
'
+_0 zies
+'
When operating attachments select a ground speed
that will suit the terrain and give best performance of
the attachment being used.
es
:Sedan
s L£ _S
7v©es
qure ira{
Do not mow grass when t is wet. We_ grass wii :aug
mower and leave undesirabie c umpso Alow grass :re
de' before mowing.
o
.:,_o< s tt .i_vet_ awnwh(s tiswet. Wet grass tends
_- _'__ *_ < a_d nterferes with the muichina act on.
-he ben: r:_se ',.esew your awn is tt<_eearly attemOOno
s ss_,_. $,
.....
_ns t.....
e :_rass has dried and t_-_enewty cs area
s be exsosed tO the "_ _÷
i'eiitoweic_Titi-<_
°ieiq1_so_a_
:"_o mnw#_ n < #_-#,,r_,++h=op one4h rd of the grass
.,o, m",,"extreme!v heavy _ ,u-h _r_
:eoce vo:.z wdh o; cu£ nd mow siow_y
f grass is extremely tall it snoud be mowed twice _o
reduce toad and possibie fire hazard from dried cip-pings. Make first cut reiativeiy hgh the second to the
desired height.
Atways operate engine at full throttle when mowing to
assure better mowing pedormance and proper ds-_
charge of material Reguiate ground speed by se!ect.ing a low enough gear to give the mower cutting
pedormance as weit as the quality of cut desired.
TIPS
t ages,
When mowing iarge areas_ staR by turning o the rgr:t
so that clippings will discharge away from snrcPs
fences, driveways, etc. After one o_'two rounds mow
in _he opposite direction making eft hand turns urmi
finished (See Fig. 11 }.
._
MOWfNG
IMPORTA_T:
FOR BEST PERFORMANCE.
KEEF
MOWER _<_ub
........#_
_o .......
=RE_ OF BUILT-UP GRASS ANn
TRASH. CLEAN A R =_,,_,, USE.
'_ -he speciai m._c_v*g btade will recut the grass ciioo
pings many trees and reduce them in size so that as
bsey fa onto t:,e awn they wiil disperse into the grass
, ,,_,,.t_,_
_s,,_,the mulched grass wii
b odeo_ade q ;_c_v o srovide nutrients _or ,_o lawn.
x_way% mu;cr, wtdyour highest engne (blade} speed
....
.........
:: t_is wH z¢ovde.....
the best recu_ing acd,,+r
,_" of the
o
3rass
ants
orass
:}.: :_ea me -_u_had
corsditons
#7sas}, _e.....
a second tree o
cui mow across or serDenqmular to the first cut _s_o_.
_,;4J evour cu; asa_emfomweektoweek.
Mow
:oHF_to south one week then change to east to west the
nexi wee_ TYs wi he!p prevent matting and graining
of the iawrh
FIG. 12
FIG: 11
15
ES
Change
Engine
CIean Ai
i
,
!
i
i
i
Oi;I
Fi!ter
+
C_ean A_r Screen
hsoect
MuffledSpark
A_ester
i
i
T
iJ
i
RepJace Oit Filter (Jrequipped)
C_ean Er*_gne Cooiing Fins
Replace Spark Ptug
I - Change more often wb÷n operating under a heavy ioad or in high ambient temperatures.
2 _ _e_viee mo_*e _
wber_ opera ing in d_rty or dust_" conditions.
3 - f a_uip_d
_
_s*_
fl_e_; charge off every 50 borers.
$ - ;,esiace btades mete e_÷_ wh-a_}mowing ir_ sandy soil
5 - !f equipped
6 - Not required
with
ad}ustab!e
if equipped
system.
w4th maintenance--free
batte
7
7 _]qghte_s _nt ax_ pivot bo_t to 35 _.4bs. max m_ m
Do not ovedighten,
LUBRICAT_ON
CHART
The warranty on this tractor does not cover items that have
beer_ subjected to operator abuse or negligence.
To
receive fui[ vaiue from the warranty, operator must maintain
...........
ir_stmcted ir_ t_qIS
' " manual:
So_'_e a_n_sstments w[l! need to be made periodically to
maintain your tractor.
creditOr"iV
_u_
ae _s in the Service and Adjustments section of
t_fismanuat should be checked at bast once each season.
Os,'ce a year you shouid repiace the spark plug, clean
or replace air filter, and check blades and belts for
wear. A new spark piug and clean air filter assure
proper air-fuel mixture and heip your engine run better
arid iast onge_.
BE!::_O;ii{}_EACH
'
USE
Check engine oit b_/et.
C_eck brake operation°
,,,
_
SAE 30 OR 10W30 MOTOR OIL
Check tire pressure.
Ciseck for loose fasteners.
(_
16
GENERAL
PURPOSE
GREASE
(_ REFER TO CUSTOMER RESPONSiBiLiTIES
"ENGINE" SECT1ON
IMPORTANT:
DO NOT OiL OR GREASE
THE PIVOT POINTS
WHICH HAVE SPECIAL NYLON BEARINGS.
WSCOUS
LUBRICANTS WILL ATTRACT
DUST AND DIRT THAT WILL SHORTEN
THE LIFE OF THE SELF-LUBRICATING
BEARINGS.
IF YOU
FEEL THEY MUST BE LUBRICATED,
USE ONLY A DRY, POWDERED GRAPHITE
TYPE LUBRICANT
SPARINGLY
ER
TO SHARPEN
BLADE
(See riga !4}
Always observe safety rutes when performing any maintenance°
Care should be taken _o keep the biade batancecL An
_.Jnbatancedbiade wAt cause excessive vibration and evem
tsa; damage to mower and engine.
BRAKE
+.
OPERATION
If tractor requires more than six (6) feet stoppin 9 distance
at high speed in highest gear, then brake must be adiusted.
(See '%0 ADJUST BRAKE'; in the Service and Adjustmerits section of this manual).
T?,e D!ade can be snaraened with a fiie or on a grinding
_ee. O( no_ anem2x x sharpen wniie or} the mower.
cnecK mao_:_
ba_ar_ce you v. neeo a 5/8 '_diameter
_ee_co_
. _n o_ acoNes_ancer
_Whenusingacose
ba_ss_ancer, renew ERe ns_rucsons suopted
}:co
TIRES
_
Maintain proper air pressure in at tres (See "PRODUCY SPECIFICATIONS" on page 3 of this manua!}.
+
Keep tires free of gasoline, oi, or insect cor_troi chemcas which can harm rubbe.
_
Avod stumps, stones_ deep ruts shar_o obiects and
other hazards that may cause tire aamage.
:i-i@ C_?iqTO_ qoe
NOTE: To seal tire punctures and prevent fiat tires due to
stow feaKs, tire sealant may be purchased from you_ oca
Da_s deater. Tre seatant also srevents t r_ _:w r_ _,_.,'_
.....
_.i }<-_s_
D@ .:£-}N_e[e£
3uY are
r_c%
.£K_4TET_t i0L£
coKosiono
BLADE
CARE
--%'p
i/=;:" IOLY
For best resutts mower blades must be kept sharp.
@ace bent or damaged blades.
BLADE
RE_4OVAL
.
"<..--_.>--
BLADE
Re-
(See Fig. 13}
o
Raise mower to highest position to aIow access to
blades.
_
Remove hex bait, tockwasher and flat washer securing
blade.
o
Instal new or resharpened blade with trailing edge up
towards deck as shown.
o
Reassemble hex bolt, lock washer and fiat washer in
exact order as shown.
FIG. 14
Your tractor has a baReh_,charging system which is sufficient for normai use. However, periodic charging of the
battery with an automotive charger wit extend its life.
o Tighten bolt securely (30-35 Ft. Lbs. torque).
!AaPORTANT: BLADE BOLT IS GRADE 8 HEATTREATEDo
o
Keep baReG7and terminals ctean.
.
Keep batter ! bolts tent.
Keep stoat vent hoies open.
NOTE: We do not recommend sharpening btade- but if you
do, be sure the blade is balanced.
Recharge at 6-t0 amperes for 1 hour.
TO CLEAN BAKERY
AND TERMINALS
Corrosion and din on the battery and terminais can cause
the baSe%, to "ieak" power.
L2.==°
Remove terminat guard.
o
Disconnect BLACK battery cable first
then RED
baser}, cable and remove batteR/from tractor.
Rinse the batter ! with plain water and dry'.
Clean terminals and battery cabJe ends with wire
brush untt bright.
'
WASHER
o
/
*A GRADE 8 HEAT TREATED BOLT CAN BE
IDENTIFIED BY SiX LINES ON THE BOLT HEAD,
FIG. 13
17
o
Coat terminals with grease or petroleum jelly.
o
Reinstall battery (See "CONNECT BATTERY" in the
Assembly section of this manual).
After oil has drained com@etely
and tighten securely_
.__,he_.
........c,eRs for deterioration and wear after 100 hours of
operaton and replace if necessar?° The belts are not
,:[email protected]_, ,-_.Replace b÷_s if they begin to sfip from wear°
TRANSAXLE
Refill engine with oH through oHfin dipstick tube. Pour
slowJy_ Do not ovedHL For approximate capacity see
'PRODUCT SPECIFICATIONS"
on page 3 of ths
manual,
COOUNG
x>._ofan and coofinq_ fins of transmission
c_ean to _sssure proper cooling°
re@ace oi! drain pug
Use gauge on oit fill cap/dipstick for checking love. Be
sure dipstick cap is tightened securety for accurate
readinq_ Keep oit at "FULL" tine on __Ip,_
_.__""
,_,,
should be kept
Do so f: erupt to clean fan or transmission while engine is
_Jhiie the trar_smiss on is hot.
°_S/r; :)Or COOi
nq
fsN
÷O b a sure
OiL
DRAIN
PLUG
fan blades are intact and
ss::}ect cooing fins for dir% grass cfippings and other
m_a_:erias To ?revent damage to sesJs, do not use
::_:p
sued a o high p_essu_-e sprayer to ciean
so: _gi:ns_
,j
_......._ ,_
:c
PUMP
OiL FiLL
CAP,giPSTSJCK
rLbD
....
.-"""
........
"/_
was _.=,_e,sat
factory 8pd fiuid mainte......
n .... _ for _]e @eof thetransaxie. SPoud the
"v;_-
}e_-'_( OF :eau_e
servcing
contact
VL_L_t
_.....
i levi_
u ......
-
e::; eL}. ;C L_}d SeTvce ce terideDa_meyt
£:;;,i x
CLEAN
AIR SCREEN
(See Fig, ! 6}
Air scree must be kept free of d a_sdchaff to bk ,_C'i
engine damage from overheating° ,_t_an with a wire ._ us_
orcompressed air to remove d_ and stubbo n dried (_un_
_ib_ro
$1}tc
(/);/' ;e
_'_a,_"
_' detement, oli rat_d_with API sepdce
...........
oe eo. the ol _ SAE viscosity
:>:so
cst_ ding to you_ expected operating temperature.
SAE ViSCOSKY
AiR FILTER
(See Fig. 17}
Your engine wilt not run properly using a ar_y sir iilter.
CIean the foam pre-cieaner after every 25 hours of ope_>
tion or every season. SenJice paper cartr dqe every 100
hours of operation or even/season, whichever occurs fist.
GRADES
Serdce air cleaner more often under dusty conditions
o
Remove knob(s) and cover.
TO SERWCE PRE*CLEANER
o
Slide foam pre_deaner off ca_ridge°
HOTN,: ,though
mutti-vscosity
oils (5W30_ IOW30 etc.)
imrK:ve starting in cod wea[her, these multi-viscosity otis
,>s:_t n ncreased oil consumption when used above
3£*[::o L:_ec_ your engine oit level more frequently to avoid
possib e enine damage from running low on oiL
o
Wash it in liquid detergent and water.
o
Saturate it in engine oito Wrap [t in ciea.
ctoth and squeeze to remove excess o!
Ch_;,::f: h_-.oil afte eveR,' 25 hours of operation or at least
once :_;'es _-'
f the tracto_ is no_ :sed for 25 hours in one year°
o
If very dirty or damaged, replace pre-deaner.
o
Reinstall pre-cteaner over ca£ridge.
Checkt[ _:crankcase oHteve[ before starting the engine and
atre c_,c-_eight (8} hou_ of operation. Tighten oi_ fill cap/
: psticK: securely each time you check the oJt revel.
o
Reinstall cover and secure with knob(s).
TO SERVICE CARTRIDGE
L, ,..,rs._
Squeeze it dn/in a clean cloth.
ENGINE OiL (See Figs. i5 & 16}
/);_::_x4i._e '_smpera _re range expected before oil change.
Aii oil must meet API service classification SF, SG or SH.
_
Be sure tractor is on levet su_ace.
,,
Off wiii drain more freely when warm.
,_,_:,,,.,
_oil in a suitable container.
o
Remove.oil filt cap/dipstick. Be carefu! not to allow dl_
_o erte_" the engine when changing oil.
_}
Remove drain plug.
18
aSsor;N__nt
o
Remove wing nuts and cartridge p_ate.
o
Carefully remove cartridge to prevent debris f_om em
tering carburetor.
,_
Clean cartridge bytapping gently on flat sudace. If vep7
dirty or damaged, replace cartridge°
o
Reinstall cartridge plate, wing nuts, precieaner, cover
and secure with knob(s).
iMPORTANT:
PETROLEUM
SOLVENTS,
SUCH AS
KEROSENE,
ARE NOT TO BE USED TO CLEAN THE
CARTRIDGE,
THEY MAY CAUSE DETERJORATtONOF
THECARTR_DGE°
DO NOT OIL .......
,_,_R RIDGe.. DO NOT
USE
PRESSURIZED
AIR
70
CLEAN
OR
DRY
CARTRIDGE.
inspect and repiace corroded muffler and spark attester (f
equipped} as it could create a fife hazard and/or damage.
SPARK
PLUGS
Repiace sDaFk piugs a_ tse beginning of each mowng
season or after ever,i 100 hours of operation whichever
occurs irst. Spar_ pug type and gap se_ing are srsown in
FOA_
PRE-CLEANER
A_R SCREEN
%
Re° 17
BNGINE
COOUNG
F_NS (See Fig. 18}
Remove any dust, di,_ or oil from engine cooiing fins to
prevent engine damage from overheating. Air guide covers
must be removed. Remove side panets and hood {See "TO
REMOVE HOOD AND GRILL ASSEMBLY _ in the Service
and Adjustments section of this manuaIt
o_ L,_e_n engine_ batter/
seat, finish_ etc. of a_{fore gn
K_e#._finished surfaces and wheels free of atl gasoline_
oii etc°
ENGINE
COOLING
Protec_ painted surfaces with automotive typewax,
FiNS
We do not recommend using a garden hose to clean your
trac_or unless ire e ectdcaI system_ muffler air fi_ter and
carturetor are covered to Keep water out. Water in engine
can resuR n a shortened engine life.
AIR GUIDE COVER (BOTH S_DES) '\
F_Go18
19
E
CAUTION:
o
o
o
,
;
o
DJ
BEFORE PERFORMING
E
ANY SERVICE OR ADJUST_IENTS:
Depress ciutc_brake
pedal fulty and set parking brake°
Place motion coRtrol tever in neutral (N} position°
Place a_achment c_utch in "DISENGAGED"
position,
Turn ignition key "OFF" and remove ks?_
blake sure the blades and a# moving pa_s have completely stopped.
Disconnect spark Drug wire from spark p_ug and piace wire where it cannot come in contact
with plug.
.... i:;ESiiOVE #_OWER (See Fig° 20}
:,47, e v.4 be ess_er o remove from the right side of trac or_
:>}_,ce£_tiachme_-. cctcff
'DISENGAGED" s_ositon.
,.s(w_ttachment
:west positio:_.
_:etoffe_s
_,
ifi ieve_? rward to owermowe
_ne p
Z co_nect cutch
e
to its
ey,
rod _om cutcn
iever by emoving
_}er spris!{_.
.
[} xsct nect sqt°sway
"e cingretainer
spr
"
£[_' c
;n@ct
sIspelhsor_
bar Trom cr_assis bracket by
I}
_r_3s
_oRs
year
deck
Dr&sk@ts
,: _-_ovr_gretainer sp i_sgs,
Dsc ;nnect front nks _om ceck by removiFg _etaJnei
SD:_S.
,_
ss8
lift _eveTto _s{s÷ suspension arms. Siide rnowe_
c 9 tom _rder t_acto,
_4POA3 ANT:
IF AN ATTACHMENT OTHER THAN THE
MOWk_F S TO BE MOUNTED TO THE TRACTOR,
:,_1i?_OVE THE FRONT LINKS.
£_
_ALL
_OWER
(See
Fig.
ANT_-SWAY
20}
BAR
RETAINER
SPRINGS
(BOTf_4_ S_DES}
_-
_se
attachment
tiff iever to its h ghest position
-_
Sde mower under tractor with discharge guard to right
::_e of tractor_
_
,
Lower tift iever to its iowest positios,
stat mower in reverse order of removal instruct ens,
F_G. 20
2O
TO LEVEL MOWER HOUSING
FRONT_.TO_oBACKADJUSTMENT (See Figs. X3 and X4}
_B_PORTANT: DECK MUST BE LEVEL SIDE-_TOoSIDE IF
THE FOLLOWING FRONToTO_BACK ADJUSTMENT IS
NECESSARY BE SURE TO ADJUST BOTH FRONT L_NKS
EQUALLY SO MOWER WiLL STAY LEVEL SIDE-TO_
SIDE
Adjust the mower while tractor is parked on leve! ground or
Make sure tires are propery inflated (See
"PRODUCT SPECIFICATIONS" on page 3 of this manual)
If tiros are over or underinfiated, you will not properly adiust
your mower.
SIDE-TO-SIDE
ADJUSTMENT
7o obtai£the oest cu_ir_gresuitsthe mower housing
sbou}d be ad}usted so that the front is approximm@y 1/8'_to
i/2' ower than the rear when the mower is in its highest
(See Figso 2! and 22)
Raise mower to its highest positiom
_
Atthe midpoint of both sides of mower, measure height
from bottom edge of mower to ground. Distance "#7'or
both sides of mower shouid be the same or within t/4"
of each other
_t adiustment is necessary
side o1 mower oniy°
Check ad}ustmer.,t on rght side of tracto< Measure dine
:enc_-:
__)_ d <ecty r _ost and behnd the mandrei at bo_om
_s,cCee_ J:;ower ous ':gas sr_owr_
•
_efore rasing any necessa_.., ad ustments check that
::oth fermi nks are equa! in ength Both !inks shoutd be
approx mate y 10-3/8',
t [ ;<sq<c _'_oeq<.,a n eng,°:, adust one ink to same
en<xh as ot er sk.
, _<s owe_ f_-os_o mower oosen nu_:"" on bo_h from
make ad ustment on ,,,,e
aut on that side.
To iower one side of mower, loosen lift tink adjustment
nut os that side.
NOTE: _acnfuttturn
height about I/8.
o
O_
__stm_s_
_ ae/_-"
_
Recheck measurements
__ +Wh_
*_" cnanqe
"{KS ar_ equai
._
mowe_
after adjusting.
,
_
ritN
:}e! _ of t iT'S,
Whendsmsce
D s i/8' e s2' owerat rontthan
i_ea tqh/er
<us<s'_ s:__ain<tt_tq_nio< *n both font
.
o
in<s.
To raise front of mower oosen nut"F" from trunnion on
both front nks Tighten nu "E on both front Jinks an
equai number of turns.
When distance 'D'_is 1/8" to I/2' !ower' at front than
tea< ti hten nut'F*' against trunnion on both front Iinks.
Recheck side4o-s de adjustment.
FiG, 23
BOTH FRONT UNKS _WST BE EQUAL
iN LENGTH
\
LIFT LINK
ADJUSTMENT
NUT
FJGo22
NUT "E"
NUT "_"
FRONT LINKS
21
TRUNNION
FIG, 24
TO REd'LACE
MOWER
B_BE
DRIVE
WITH PARKING BRAKE "ENGAGED
NUT 'A'
BELT
(See Fig° 25)
°Themower blade drive belt may be replaced without tools,
Park tr4_ tractor on _evel sudace. Engage parking brake
B=_ _.F EMOVAL
,,
Remove mower from tractor (See "TO REMOVE
MOWER *_in this section of this manual}.
,-_ Wo_: her off both mandrel puJieys and idler puiJeys,
o
Puii belt away from mower.
ARM
B£L7 INSTALLA]]ON
_ ns_aii new belt in reverse order of removal
,_
f,i!a_<esur_ beit is in ait putiey grooves and inside a!l beit
/
:_u deS.
_
DO NOTTOUCH
TN!S
NUT._FFURTHER
BRAKE
ADJ_STo
MENTtS NECESSARY CONTACT YOUR NEAREST
I R_ZED SERVICE CENTER_EPARTMENT
ns_.;:,i mower _n reverse o_-derof removal instructions.
TO REPLACE
BaOTION
DR_VE
AUTNC,,
BELT
(See Fig_ 27}
Pa_k the tractor on ievei su_taCeo gage
par_Jng o_a_:e.
For assistance, there is a beit instatiation guide dece_ on
bottom side of left footrest
o
Remove mower (See "TO REMOVE MOWER" in this
section of this manual.)
o
Remove upper be_t keeper.
F emove belt from stationaP/idler
o
\\/
o
MANDREL
PULLEY
o
Install new belt by reversing above procedure.
!_IPORTANT:
MAKE SURE UPPER BELT KEEPER IS
POS!TIONED PROPERLY BETWEEN LOCATOR TABS.
FIG. 25
TO AOJUST
BRAKE
(See
and clutching idler.
Put/belt slack toward rear of tractor. Camfu_iy remove
bett upwards from transmission input pul!ey and over
cooling fan blades
Puli belt toward front of tractor and remove downward
from around engine pulley.
Fig. 26}
]
Your reactor is equipped with an adjustable brake system
which is mounted on the side of the transaxle.
PULLEY
f _ractor _÷quires more than six (6) feet stopping distance
at high speed in highest gear, then bra_e must be adjusted.
CLUTCHING
_DLEB
-_
Dep;x._ssclutch/brake pedal and engage parking brake.
o
Measure distance between brake operating arm and
r_ A' on brake rod.
TABS
UPPER BELT
_{EEPER
IDLER
l
t
if distance is other than 1-3/4", loosen jam nut and turn
nut "A" until distance becomes 1-3/4". Retighten jam
r_,_ X._:_.}nstnut "A_.
Road test tractor for proper stopping distance as stated
above. Readjust if necessa% If stopping distance is
sti_i _::reater than s_x (6) feet in highest gear, further
maintenance is necessary. Contact your nearest authorized service center/department.
TRANSMISSIONINPUT PULLEY
I
I!
J
22
FIG. 27
TO ADJUST
MOTION
OONTROL
LEVER
Fig. 28)
TO ADJUST
STEERING
WHEEL
ALIGNMENT
"The motion control lever has been preset at the facto%_and
adiustment shoutd not be necessary,
f steering who@ crossbars are not her zontai (left to right)
when wheeis are positioned straight forward_ remove stee_T_gwheei and reassemble per instruct ons in the Assembty
section of this manua.
If for any reason the motion controi lever wi_i _-_othod its
position while at a selected speed, it may be adiusted st the
friction pack located on the right side of transmiss on,,
FRONT WHEEL
0_ Pad<tractor on ievel surface° Stop tractor by turning
9nition key to "OFF _ position, and engage parkng
brake.
_"
TOE-INtCAMBER
The fro;st wnee toeoin and camber are not adiustab e o_
your tracto
f damage r;as occurred to affect the front
whee toen or camber cor_tact you _nearest authorized
sewice ce_ terideoaRment
Adjust motion contro! tever by tighten ng ad ustment
ocknut one half !I/21 turn.
NOTE: tf for any reason the effo_ to move the moron
controi lever becomes too excessive _everse tte e_:,ove
adiustment procedure by oosening ocKrs_t 1i_,sto i/2 tu_'_]
(See Pgo 29}
,*
#_e_-_ove
axe cove__, eta _-_
n rn_#an<_wassers_o aiiow
Road test tractor after adiustment and repea_:procecure f
necessa(¢o
TRANSMISSION
REMOVAU'REPLACE_aEH°?
Shoed your transmission require emova for sewce or
replacement it shouid be pureed afte£ reinsta_at on and
before operating the tracion See "PURGE TRANSM!S -_
SION '_in the Operation section of this manua.
({Y_ocku_, axe secs_e y
wBee
e_xov@
so
ose
>
( :}a
:reasd
wr_ee
coy_a{r*,re
a sGuae
_<ey _, _}o
,_
ReDa{
reasseKsoe
-,
0 _ _esrwrees
<,;nv :,kgs grooves
as@ axe
nse_< squa_e Hey
,:
Re_}ace washes and snas rata f_ng ring secureiy iP
axie groove
IRe@ace axie cove
n
earwreei
_u:;
HOT_: To seai t_e _}unc_u(es ano prevent fiat tires due to
sow leaks, tire sea ant may se purchased from your iocai
parts dealer, Tire seaant aso prevents tire dry _ot and
corrosion.
WASHERS
RETAiNiNG
R_NG \
%
AXLE COVER
F_G°28
_SQUARE
KEY
(REAR WHEEL
ONLY}
TO REPLACE
HEADLIGHT
BULB
Raise hood.
PuH bulbholderoutofthehoieinthebacksideofthe
o
o
f your battery" is too weak to siart the engine,
_f 'umber
cabies" arc used'for
t_:::_,n9 foitow this procedure:
Replace butb in holder and push buib holder securety
back into the hole in the backside of the gri&
Ctose hood,
_NTERLOCKS
it shoutd be
emergency
AND RELAYS
Loose or damaged wiring may cause your actor
poorly, stop running, or prevent t from startin _
::o _ur_
_'f_:_O_:iTANT: YOUR TRACTOR
tS EQUIPPED WITH A
L dOLT NEGATIVE GROUNDED
SYSTEM. THE OTHER
MUST
ALSO
BE A i2 VOLT
NEGATIVE
GROU_',iDED SYSTEM.
DO NOT USE YOUR TRACTOR
_::;ATTERY TO START OTHER VEHICLES
o
_, _e
_-O ATTACH JUMPER CABLES
Replace with 30 amp automotiw_-type ptu_-_
fuse hofder is iocated behnd the t_as,:
,_
_
Connect eac_s end of the RED cabie to the POSITIVE
{_- terminai ot eacr_ ba_:leql taking ca_e r_ot to sr_oR
aga_ns[ chassis
Co#_nect one end ot ti!e BLACK cabte t} the NEGA-TiVE (-} termina_ of fulty charged baSery.
TO REMOVE
REMOVE CABLES, REVERSE O_DER -
'_
_,4oACKcabtc first from cr_assis and then from the futiy
HOOD
AND GRILL
:x_g;_
:,_s_ i_e
ASSEMBLY
(See Fig. Sl}
Connect the other end of the BLACK cabte to good
C dASS_S GROUND, away from fuei tank and batte.ry,
O
Check wiring. See e_ec_rica wirn_
Repair Pans section o_ this msnuai
o
Raise hoed.
o
Unsnap headlight wire connector.
o
Stand in front of tracton G rz'.Sbhood at sides, tilt tows rd
engine and lfi off of t_"actor,
o
To repiace reverse above proceaures.
R_c.IDcable iast from both batteries
HOOD
•\
\
>.,
{
"POSI_VE"
(+}
"ItEGAT_VE"
HEADLIGHT
W_RE
CONNECTOR
(-}
/
i
,/
/
/
/
/
/
FIG. 31
/
/
/
//
/
',
\/
/
1
F_G. 30
24
TO ADJUST
THRO LE
CONTROL
CABLE
(See F[go32)
The throttle control has been preset at the factory and
adiustment should not be necessary'. Check adjustment as
described below bdore loosening cable. If adiustment is
necessary, proceed as fo!tows:
o
With engine not running, move throttle control Iever to
fast (_) position.
Ch_k that swive_ is against side of qua_er circie f it
is not, Ioosen cable clamp screw and pu!i cable back
untit swivet is against quaker circie_ Tighten cabie
c_amp screw securely.
SWIVEL
The choke controt has been preset at the facterv and
adiustment should not be necessap!_ Check ad#ustment as
described below before loosening cable. !f adiustment s
necessaq7, proceed as follows:
o
With engine not running move choke control (Iocated
on dash panei) to full choke (IX) position
o
Remove air c_eaner cover fitter and cartridge pis.te to
expose carburetor choke (see "A_R b,LT£, ,"
the
Customer Responsibilities section of this manuai}.
o
Choke shoutd be ctosed. If it is not, ioosen casing
c_amp screw and move choke cable until choke is
completely ciosed. Tighten casing c!amp screw securely.
Reassemble air cleaner°
o
CASING
CLAMP
SCREW
F_Go33
25
SKRV!C£
AND ADJUST[IaKNTS
/4 _ER_K)I
;._,' r = _c FL:'y L"
/[
:C:_
i- _'41RJ_FKED_..=
_
L_o'::'::_*KED!I:ZITr_ZZ,,GII!L_
-,
,:p l:. _{_:
-r':'
....
I
:"'Z-,
C -'=`
-'=---'_---,,_
_-
_*-._G ERe d L
m;GH
ZFEZD
-,,.-'-"....
i
_=:_:-_
....
I} Z A'-'
TmE S
.L,Fi.C:_
E.':FE_ENCE
-C
jL'STN,
.......
SEYTit;]
,_.DJb. c.... ,;•.,;.
u_,._,
c_ L'_--._EK
_."Av `Z
C©h-'
=.b
E ;_ "dl C ::
EC
'_ _'_"
} , .r
.
_£--_
I
=q_[_:_[._;-+'i_
i&
"o-
AOi[i_
• -'-K:
_
I_V_:
"t_ #LIil
i_
, ,_-.;_,
G_,"_'FI@_L.-qII[,{
4.
'_
;
'0
c-
K
_:,-,
[.'Q'_;
I]
[IC
50 -T,:.,, ;÷V_:;, _K S OH [,_
_, pg.,3 [IO % hO d
,'_T_}c-_r'_
_.HC]
i'.
,:s
f]:JL:_-J
SCI-_V¢
bZ]
JS[
K
£
._c_,:<. _'rI:'_:?OO_:_4OOR!M
, _;n._e [c ROla t,r,-'[_;e !_vel _ga!]st tt,ie speed scTew
-_ -u:_ _, _c,_ speea screw to obtain 990 to 12u9
de'.-lu_;se ti] .otTe te,/_r.
_,-Z_L:_]-%
TEST-
.- I[ to-t,:
........ cc;--rc_ i+-:verTr:>m,::uw_,(_)
q,
i, E,-rC_r:'9
[':'-l[_K:i
( _ L'<S,
to fast (_---{_.
,,
tJm ,:lie r,qb:[i:_
c-u{ '.t.&:;nle,-C_OCkV_..S6
-__. turF. F,epeat _ea[
_n<-continue [2 aclust, if r:ecez-s[:r< until er g:ne acc.. -
:i-b L_!Tr)'_
,,.
-,,-_
_ r,=ed
STO_-__s f_aclor% = a.diugted.
__.;,_ ._£ }T]ay r,ssjj!.
Do
r.o[
_.'J!US_
2_
. _.b
u E_IY C :
:I'-:V -,=
E'_:
,
L'-'L
"iF_ _ EL ? " :
,,-Z.K SPSZ'_
. CI::L:,
...........
S.
, -,E_
'-CT
E_:T
_
ZD
Tr-Z =-,.-.
....
;_ _.;i'= - .="-_.>
'. EF;DoE L
_0"'- m O.F,_'_"-m
1.E._pTB_E_T
-
:'_ZZL
; D.,_-._
- t__,
Immediately prepare your tractor for storage at the end of
the season or if the tractor win not be used for 30 days o
more.
FUEL SYSTEM
_@PORTAWR T IS MPORTANT TO _REVENT GUM
DEPOSITS FROM FORMING _N ESSENTAL
FUEL
SYSTEM PARTS SUCH AS CARBURETOR, FUEL F LTER,
FxJ[_. HOSE OR TANK DURING STORAGE
ALSO
EXPERIENCE NDCATES THAT ALCOHOL BLENDED
=UELS (CALLED GASOHOL OR USING ETHANOL OR
{_4ETHANOL)CAN ATTRACT MO STURE WHICH LEADS
70SEPARATO _ AND FORMAT ON OFACDSDURtNG
STORAGE
ACDC
GAS CAN DAMAGE THE irUEL
:q" STEM ()_ AN ENGINE WHILE b4 STORAGE.
Remove mower from trac_or for winter storage
When
mower is to be stored for a period of tree, ciean t thor-oughiy_ remove aii diq, grease eaves, ec. Store r_ a
ciean d_' ares.
Ctean entire tractor (See"CLEANING" i me Customer
Responsibilities section of this manuaiL
o
!nspect and replace bets° f necessae/ (See beit re.placement instructions in the Sewce aria Adiustments
section of this manua }.
Lubricate as shown in the Customer Responsibilities
section of this manual.
,_
Be sure that aft nuts bolts and screws are securely
fastened. Inspect moving pa£s for damage, breakage
and wear. Replace if necessary.
o
Touch up aft rusted or chipped pain,t sudaces; sand
tightly before _aintingo
F@Jycharge the battery for storage.
o
After a period of time in storage, battery may require
£kar' t:se fe
,_
:::.ta_ the engine an@ et t rim until the fuei linesanci
carbu;_elor Rye emb<y
"
;,ever use engne or carburetor cleaner sroducis in the
Je e:]_<or sermanem: {samage m8%_occur
Jse es< ue next season,
_,
ta._¢
iqOTS2: =ue stabiize_ _ s an acceota_e
aternatve
n
-c:s_qzngt_sefor
ate of rue gum<seoosits::v_ingsto
__:,_ge, Add stab{ize
_o gasoine
n rue tan_: or storage
contame.
Aiways toiiow 8no mx ratio found on stabiiize_
containe_ iRun engine at ieast I0 minu_es after adding
stab izer _o ailow the stabilizer to reach the carburetor. Do
not .crs_n the gas tank and carburetor if using fuei stabiiiZero
Drain bit {with engine warm} an@repiace with ciean engine
ci.
(See ENGD4E _ in the Customer Responsibilities
section of this manuai}.
BAKERY
o
_,
Remove spark plug(s).
o
To help prevent corrosion and power leakage during
iong periods of storage, battery cables should be
disconnected and battery cteaned thoroughly (see "TO
CLEAN BATTERY AND TERMINALS" in the Customer Responsibiiities section of this manual)°
o
Pour one ounce of bit _-"rouyh
' _ soark _,_uu
7" Z hoie{s] into
Turn ignition key to "START" position for a few seconds
to distribute oi,
Replace with new spark p_ug(s).
After cleaning, reave cables disconnected and place
cables where they cannot come in contact with batte_i
terminals.
o
Be sure battery drain tube is securely attached.
o
Do not store gasoline
o
If batte_.! is removed from tractor for storage, do not
store battery directly on concrete or damp su_aces,
_
Repiace your gasotine can if your can starts to rust.
Rust and/or di._ in your gasoline will cause probiemSo
,-'
if possible, store your tractor indoors and cover it to
give protection from dust and dirt.
from one season
to another.
Cover your tractor with a suitabie protective cover that
does not retain moisture. Do not use plastic. Plastic
cannot breathe which altows condensation to form and
will cause your tractor to rust.
I_IPORTANT: NEVER COVER TRACTOR WHILE ENGINE
AND EXHAUST AREAS ARE STILL WARM.
27
G
CAUSE
CORRECTION
•
C'u_ of fuei
2.
3,
Engine
Engine
4.
Bad
5.
6
7
Dirty air fter,
Di_ ¢fuet filter
Water
n fuei
not'CHOKED
flopped.
spark
_pro
ery_
pk_g.
I
Fi_I fuel tank
2.
3.
See_OSTARTENG_NE'
Wait severai minutes
4.
Replace
5
6.
7.
Ctean/repiace
air fi}ter.
Replace fuei filter.
Drain fl._eItank and carburetor
gasoiiRe
8.
9.
_O.
:-_i_r_ _c
¸_!
.pose
o_ {_amaged w_fin,
CA<rb_ (eior oLt of adiustmen.
_'_q
i}sv
11
e vaives
8.
9.
out of adius_r_enL
10.
sir tte_'
Weak
e
_
dead
batter/
.rtv
tse te_
Stafeor@iHvtue.
:L
L_C::;: <} @arnageovvn:r_
alsure;:ol
e
o {csustme
Contact
s_c on.
:o s_e__:
piug.
and repiace
_etii tenet w_
C_san/re_)acs
_:s
rue! f}te
an authorized
:ew
se_
c_
ce
' :'e"'-'s
@ f!te_
or eDsc
_'
Repiace _ue filter
Dranfde_tankmw;
:{
nO_:-eraion
at_emb_n_}
Ciseck ai wtnnc.
See '% A{]iust Carr:urHor
section.
Recharge
:
5
spark
before
6.
C3ecFaiwirme.
_ .......:See "TcAdius
ef
Cast/
w:
a o_-:
3e _ s
:-_,rvcs
;£d_s ST :"
,ectc
8.
_F#_ne
valves
out o adss_ment
C'_utcbib_ake
i£n_ir_e
Loss
Sf
Excessi,_e
siicks
but wHI not
:S:_wer
vibratiorl
De,at
not desresss8.
2_
S
Attachmert
ctzc_
is ersgagee.
Week
or oesd
saue
v,
4.
5.
_}bW_ USe.
Corrode(_ ba?ew
6.
7,
.pose
F.auw
8.
Faui w soieaoid
or sta_er.
9
F{_u ty opere_or
T}resence
termiaais,
I.
Weak
Corroded
batter/termfna!s_
Loose or damaged
w@nng
or _ead
4.
FauIty
soie_od
swilchfes}.
batten/.
or staFs_.
i.
Cutting too much grassRoo fast.
2. :nFX_e n CHOKE" pesitior.
,3. Buiid--up o qrass, ieaves and trash under mower.
4. D:tva
fitor,
5, Low o_ evei:@m/oil.
£!!.Fauty sperk piug.
7
D_yfue
fter
8. Saeord
tyfue.
9. Wa_er in fuet_
i
Depress c uteri/blaKe perle
Recharge
2.
C_ean bakery
or re@ace
ba_ev
3.
4.
Check att wiring.
ChecWreptace
so_enoid
1.
Set in "Higher
Cut
2.
Adiust
_rot£ie
contoi.
3.
Clean
underside
4,
5
Clean/replace
air fitten
Check oii level/chance
{:L
Ciean
7.
8.
9,
Drain
:_.
s_ar_
p_uq
Re@ace fuel fiiter,
Drain fuel tank and refilI with fresh
qaso
fuel tank and carburetor,
Clean
!2.
13.
Clean/replace
muffler.
Check all wiring.
i4,
See'%o
section.
Adiust
15.
Contact
an authorized
Loose or damaged
wiPng.
Ca buretor out of adjustment,
!5_
Engine
e_4t of adiustment
1,
2.
Worn, bent or loose
Bent blade mandrei.
3,
d
Lapse/damaged
1.
2.
3.
blade.
¢
part(_,),
28
o
or change
11.
} 3.
14.
speed
_A.m
and regap
of mower
10.
piug wre
or s[a_xe_.
position/redxce
icons.
D_'ty eng_e
Dirb,!cbgged
e_,,3@_ancs'
termmas.
air screen/fins.
muffler
Spark
! !
12.
Se_V/,C@,:s
i.
gasot ne and replace
Connect
and tighten
10.
vaives
£}ontac1 a_1 atzno[tzeg
2. Osengage attacr_ment cietc"
3
Recharge or re@ace Dattep/
4
Repiace iuse
5. Ciean battery termma_s
{S. Chec_ all widng.
7, Cteck/re_tace _gni_io swi!cr
8. ChecWreplace soienold o:_s_arter
9. Contacl a_ aut_°_orize{_serwcn ce:-te_!eepar_'mer,L
of <samaged winn_.
ignition switch.
2.
3.
8.
engine
f_et filter
spark ptug
retili
rse.
_ark wth
fresi
w.re
air screen/fins.
Carburetor
_ in 5srv!ce
service
cgnt,gr
P,,sius_menr:
r{ep/: Truer
Replace blade. Tighten biads boit.
Re@ace blade mandrel.
Tighten loose part(s). RepJace damaged
psr, s
:
aSH
_ngag_d
POOr OUt _ b_never_
7,
V_#OYS Den#
2,
[!4OW@[
Poor grass discharge
3.
r}U_JQUD {:}_ eras_,
_er':t
_,
_}IOLT_s_Q {TtGW@F QeC_< ven_
e;a4se
i.
_}DStfUCT!OP
WoN}/c£Rv(
_,
_Z_oz_r
ilk
_m_'ozeF} oiaae
*.
_r}P(3 ne
Loss of drive
.....
_
Engiaa "backfDes"
when t_rning engine
"o F
_
vve_
_oweF
{,.
Li;&_q/utlevevi
6.
W_rn
!Jnaer
Tqowe_
_CieS
arow]i2
F,qowcr
:_iee£_
!inae
;FGH]
-v/)£W;
_L_]_CqD
Tie4q:e_
stqe
oi
rnanere_
t_rcunG
_iaf]_r_[_
O©STYlJC'_
-_eO}Rce
:Rov,_er
_@r)[RC%
'Ci_
rnanorei.
i!÷OH;Ci='
©ldL]e
\co
u_'C(
Grwe
_.xa!;
L _tlev
cc
Siow
iRs[
P _- "C
t
aLaCK FK31"eVe[
fiT@
rqower
place
-<e[Nov_,_
K;ower
e:a@e
Dolt
,£1ecK.
TIOUS_iSC
T.r: ©oeT_ ',/eni
7(_H.:,£
,rnan_reL'-:',
erase
DePI
s_aG£.
_@V6
,-._eK.qace
C_U_CD _eenaR!sm
sDeec
3.
an@ was'i
_r_c: _rasr_
soeeo
4
7.
8.
9.
10.
11.
Battery wi!i not charge
_s/e_
tee%'ee,
eo
ote[
_eo}ac_i
ma_qar£,i
ie_,Jes
2,
_i.
Hea_ight(a)
not working
(i'l so equipped}
DV_aS
TtOx{leVeL
4.
£1rass.
d!ower btades wiiI net
rotate
Of [OOSe
QecK
£
:V'
."qS?
r
!._@L,,
_.f!ke'
N _/1G[e}
te
_owe!/
OF:
£!rpce
_]WQ_ n "'_-A_w, _"
oosvJer,.
_DO;:G
;-:-t%S (}
r.'.eTore
rriow_R¢
t }'_%'_tt Q{¢C
Parr" OFeSSUFQ
or _oose
maae,
_i_.uk_ice/sn?zf
Bu}idu_:}o_ grass _eaves ane aasn unaer mower.
i',/_owetdrwe beK wens
_ta@es tmu[[ )eylv p,s_a_ea,
knorooer b_aaes uses.
C[oqgeo mowel seek van[ no!as from DUttGUDO!
_r[ZSS.reeves. ERe WaSh s.rouRd manare;s
-
9en
2face,
Fienqsta ! elaaes snare
0
-k_!en
D_ade
DOX
.Neen bnoe s}qe o_ mower noumnG
.._u:J_ac_mower @rive De!T.
RaDiate
w_tn
Napes
eage aowr,,
tiered
Oiean afoun@ manatees
tn th}s
manuai
re peon yen,; noes.
i.
Switch is'OFNL
2.
8.
4.
5.
BuD(s) burned out.
Fa@%,tight switch.
Loose or damaged wiring.
8Iown fuse
£.
"urn swi_cn ';'ON"
F eeiace buib(sL
ChecWre[} ace ignt switch.
Check wiring and connections.
Replace fuse.
I.
_.
Bad ba_e9 ce!I(s).
Poor cable connections.
i.
2.
Replace battery.
ChecWcIean aiI connections.
4.
_au tv regulator (if so equipped).
Faulty alternator.
3,
4.
Replace reguiator.
Repiace alternator.
I,
2.
3.
Freewhee_ control in "disengaged" position.
Motion drive belt worn, damaged, or broken.
Air trapped in transmission during shipment
or servicing.
i,
2.
Place freewheei control in "engaged" eositien.
Re@ace motion drive be_t.
_
Purge transmission,
1,
Engine throttle control not set at "SLOW"
cosition for 30 seconds before stopping enaine,
!,
Move throttle control to "SLOW" position and allow
to id!e !or 30 seconds before stopping engine.
•
'
i
29
SE
30
_>_.
_
4_;_#_%_!
_
_#_%_tW
_
_
_
_
_
"9_
,=,<_
_>u
_,,_,_
_
BLACK
......
]
:SWITCH
....
........................
,E!-i.... ...
£'_L.:C _-' - =-
-- _
BLACK_@
3ROUNDING
TONNECTO_
A
£PAI_K >LUQ
GAP
PLUGS ON
°_'V4!N CYL. ENGINES}
DI 'C
]B V©L_-*I
]HAH('-,I_qG
.............................................
"-=
L'i]:....................
-.:ODE
A<
M_N
;
_YSTEM
&i.TERNATOR
L....... "."__.........................
r-! T:, £,{, MH,_ @ 3600 RPM
=-
LIGHTS OFFT
HEADLIGHTS
3
....
v
3600 RPM
D SCONNECTED
_....
i.T---<
"---2£
b
::_T_--TJ
L-T-Li
]
IGNITION
POSITION
S\.-'¢ITCI1
CI£;IC UIY
±
OF,="
RUN/LIGHT'
RUN
3T_RT
I4_IcIU"
T
_ _
:_-_ B B +
i
NO_,!c
_*
_, NONE
S ,
NONE
Li{,:T :, ii!:; THE _=
:Lti;H G ::::_
...................
_--, ' _ !:C:LRCi{:.
{_IHCALJ_'E O-if
-;-_F
c£[>!GHT_,!{T
-, ......... ,-._ ......._
'/fiLL if) !/_"- &/ .........
-/1;
,,,,=:L;!.....
_-
:.._NNE.,.,
:
-
V',q.__ L)h\l .¢£ T;-AI !DIGiNIY ill
c_,t" .rEmD'E
.........
,---i, ..,,_,£F;. -2_-:i_! LXRHT?
HiLL BECOME -_, i-_::,'-"
I"
>!,:: _'"I__'r'<:_:'_'<
D_'"
...... .:"
I ION,.
+Y!u HG INSULATEE CLIPS
OTE ;= W!RING INSULATED
_i!-s2:.:
WEF:IE REMOVED FOR
SER',i;C!NG OF UNIT, THEY
SHOULD BE REPLACED TO
:'ROPERLY SECURE YOUR WIRING,
REPAtF_ PARTS
TRACTOR
° ° _,IODEL NUMBER
.............
917o259t70
_.2-.............
-
7O
;40
i
i
/
83
32
\
52
12
I
I
1
f
9
i2
k
C¸ _
,,
_Y
C£ 5"\_
3(3
_"3
REPAIR PARTS
TRACTOR oo MODEL NUMBER 917.259170
CHASSIS
AND ENCLOSURES
29
12:3
28
/
/
58
12
53
5t
55
/
/
/
14
37
54
i
60
3
74
3
//
3
REPAIR PARTS
TRACTOB
° ° MODEL NUMBER
91 °"9
AND !NOLOSURE S
_:Y
_O
PA£T
i\fO.
I 59{ :
140S:
_ 7490{{ i
TTD55:2::
ff}27
DESCAfPT_ON
-"
t.s-
--
b-
_
"-
W'VDO
.......
L:;UT
; <SOte}@Y_@L
SF!:FYao:
',{:_592 -
_
"-
-
Dash
-s :
"_:593(;
_ _?S67/
269S8}
36-;
• UZ
:7
:8
/, !
}2
53
54
S5
5_
/
DO
C0
7I
,7.4
©_}
123
40
AO
142
-
,4 _X
i 47
"TD541437
45198X54 {:7
5521 7
:_ ig?)(£:5_
s3997_:7
17490508
! 39886
t 39887
73800400
t 4520 !
! 45202
STD552507
! 40547
STD533707
154798
73680400
STD541437
-i5730 t
152927
158z.18
! 56095
i ":}4966
t 54207
156524°
747604!2
:_L;_7 :)@_
:Z
:!,t.
_ors
:_r!iie
.u
_'(!(
:,"/Loor[es
BracKe_, [;en eUSuse{::
f:t<._ew Thcro.
5/I6-i8
x em T\,"T'
P vot _rac_:et Assembly.
tJ-u Viow_er. £e;:_ '
;:"'"AssembIv
RH .............
.... cK \:Vlh'lse_ ti4-_ .......x ,.
_'"
vva:A_er
_
913_,.)(
"_ 715 X 16 Ga,
Sracke_ Grille _ic_.off LH
Screw_ Hex Hea¢ Spiceriock
_'S ::'-)-/8 AS
Bracket Gri!ie Pickoff RH
Bo_t FinHex !i4-20
UNC X°75
Air Duct PiL 18HP B&S Opp. Twin
Bol Rdhd Sqnk 3/8-!6 UNC x 3/4
Dash Lower STLT
Nut Crowniock
1t4-20 URc
Nut Crown ock 3i8-I 6 UNLI
Bi'ac_(et bhl
STLT
Screw
Bracke_: _Suspens_ors F_on_
Piate melnforcem_n_ STLT
Back:rest Swaybar Ch_ss_s
Br_}c_et Footrest STLT
Rod E rot '-'"_[-_ood
L<.O_ )-_ex Hd
/,-z_ Uric x 3/4
NOTE: All component dimensions given in U.S. ;r c'r_r_
iscis = 25.4 mm
35
REPAIR PARTS
TRACTOR
o o MODEL NUMBER
917o259170
,_S _
_
i
.....
" _
"_(
Jt
"
;}
72
70
/
!16
/
j,J"
26
r
@
.I
51
87
21
35
_/39
32
g7
36
19
5S
SO
84
16 104
/ t00
55
77
100
TRAOTOR
Ha,
-- MODEL
iIUt IBER
%" ........
".......
9£SCRIPTIOI
.
-; '; - 70764
5
;7T955114-3
:11:: 1!-!_71<
........
1] .:tTN:7
1;:-31 :;R
....
171 911}201 £.
....7
: 4T
""
"2
}::::}(
21
/
....=
2773% 07:7
.....
2£ £ 11:
<
':. : :J: '7¢2}
T FgEY_S&X e iksseISSDiW
:2 i 47_4L7
{......... _yS 99..£
(}
s{_
(S
19
Xi
3, _)So ,_C:Y',
',
74490544
STD54.s4}
q 7_D52.:? ¢
:-77a=-;1+
{ 0D{; i
Quoin(7 :% sn
i L.2iev, T s:r:-x xie
SaG Sh;?+ Fencer S_;. T
Pi_. Co_er
I 6 < ] CA(."
{boi N.A.i.it]n::
:!i,i$--!8 .J< ::
_'tJ( LOC:,rfiix_.'_11
<".-,
1:.'i
b i,J:
.ig
Boi F
-wx
{ t.;rhc (
.i
:\iLII Lacy
t-sG;,, \' ,'b_SY7 :}./_-i :}:1
t..}oi].:£.:_-itJXe] 2" 11.11
.£0C. }.:ti<_t_:" V<:<';:
;÷ C,7,£
......
2
;_
sS= o£59t 70
.....
2..............
"/° r _1 ;J A
06888/
:
= t-_-
3inng,
?V:;
Bet Hex 7/i6-20
<eeper _et Enaine Full-Proof
}<;ce Bet Mower Drive RH
:::_tr o o_que
k_ Hydro
t2v T
'Vt_sr'e 13132 >( i-i/4
X 12 GI.
1_._=5 orqse
mn P{/d[o 0650
issaC;_- [{Dt
')£/qo,
9
0
4;;
....
E}
Oqa
i _U
'"
.5_[3
-,Q?_
....
._<-. I S _5 I <)
QW
.....
':C
,'>,
u©.:_
PS£Ti
=
Oct-:::-:.:"4W
"7"_" V"-_:1© q 7 __T
• -"
, 4 =_
40
.÷--t 0. i
-*
i 54777
42
i9tSi812
47'
127785
48
S54604
4t,
" '-'
q,_205/
O_
_<
53
BT55237i
_}
5"
STD541437
;:%)
C:U_Im _
53
55
56
_='-'
_:_)
6t
62
63
i05710X
i 05709X
o-<,D,_£Q=,
£_,,7:o _:_
o
40294
1403 2
! ]:490(:}, 12
888:] :::i
140i86
<-<
-_ si4
"_h GauGe
0 (it_ ;1)F£
< i)<
.......
,:,:,
:t.......
<: 2bi3
/. ";-5i8x '_
,£ o;a;
._ _..
A ri':. Cross Hydro 20" Tir<-s
S ',_._<eF,
IX, I
....
TTD5614"! :if
' @t:>_du_,
° '......
1°4°
#'.
130807
8TD523-; 0Y
;Y
x 4 GI. 5
&iSRe
i:'n Cotte_
,--_o:; f=,u-g
S.
D CA£
i:'::;
÷
::::
!_I'SQ)(@{]
" :;20t:
11!ans'{>,ie
Bait Sex MI 5/if-l@
JRC. :,,,,
Shatt Foot Peca
Bearing, Nyion
Wasne
Pn :_oi
Puie?, idie< Fiat.
Bolt
Bpacer
Sp:
et
;@i "
Washer
13i32 :< i;7ii6 :: 2 G,-_;ge
Pulley die_ V-Groove
Beitcrank Assembly
Retaine< Be_t
Bait
Nut Crowntock
3/8-16 _' "
/:i
£0
(7:.2
"707
,:,_
'U351050(
1£ 1 1216
1¢ i o.>,-,o.+:
7:7.g,.0S30
40"I 5(}
NUt
" ...,
gt;:
"'_
/ i \:"'-_P_
/ U[/ "'<
/ (;;1
I OA
....... <"q ........
116
- 8
12
721106i0
_5.,,"2
ii!xm.i
9
,'" YOW_ _,,
L,
_ uCk
_, _. ;:x _
"1'%: F%<O
%
j! i
:1
:]
; .. z_<)_:_,
<17
q
-7.17 Mr<G!2
;Z 8052::
142!:iL3-
"kI,
, <x
: <.i?£'"
-1
, .....
14464:1
....... b
)tO <:,-+U<ic
4t
. ::, i.j i'C
Link, Cutch
Spring, AettJr, Clt£cf;
Bol iqex 3;8/16x
1.'!4
V-Beit Ground ve
SrD_ _
i<_epeL <..,.,.nter
"_
ScrewTh
oi 318-!6 x 3,':
Co_{:c.F-ecai
i
?SSY!
' <-
UO°S'E
37
.4©:y
.51_i
'
,o_,_
I
....
3/4
X 16
_Qa,
,-t:::<: -,_, -:vdro 20" Tires
£:..sr m Rod Strig. 629/632 ID
....,,r_sr_e, 2i/32 x i-i/4
x i6 Ga.
Kiip S5304-62
Consoie, Shift
N
Seif-Thd Wsh-hd
I/4Zinc
:£et Fn He)( 5/16-t8
× 2-!/4
1":)
..:_:'-,:_
Fn. Hex 516-18 Unc x 4_- ......
L;:e F.Je Hydro 4"
;;:qr, qvdro 7"
Co_:Troi Bypass Hydro 20" Tires
:-{ets.i:;er Spring i" Zinc/Cad
.e6eet Bait Rh Hydro 0750. 1u.zu
,u
Keps Hex 3/8-16 Unc
Wasie
11i32x3!4x16Ga.
w:asner Be Iviile .501D x i.505
<
t,e-2_,
Nut Hex Jam
Topiock
:_ '_ ,..,,_"_.
Arm, Control Hydro
Screw Cap Hex 5/16 x 18 x I
B:t F; Hex 5i16-18 Uncx I-Ii4
iXt £_.shd Sq Nect4 3/8-t6 x i.25
{:_,acer Beilcrank
_.4v it er Clutching
STL
N; :::ornmose<_ d mensions
given
in U.S. inches
REPAIR PARTS
TRACTOR
STEERING
o- MODEL NUraBER
ASSEMBLY
: ......
i'
_
,
G£
'i '=
i
X
//
.
1/17
'/ 'i,
....k(:.:¢
.........
'4_.,--"_"_'_ t8
25
8
J.
-----4
/ /
z
•.
. /
///
'¢9
'/\
0
}'
//1
917.259170
REPAIR ° ARTS
TBACTOR
° o MODEL
;,(£s::.
PAH
i
2
."
4
!
39}£>8
74427
i 5C483
_fY_73
} 2 }SH
2 748X
Wheet
6
,:
:-
s
%£sys._.
ytJW_.
<
:L,L66R
,,
!7
;!7079
24(3&/
,. ;
23
"'_/(L£; _}
27501/.
;;4 m::
:}
; £co,_ ..
,:'
cs(s
.............
._
1!:. 191:314 8
£
° 74906 i _"
30
b,Dsb
,_.,,.
£
" 30465
_i;}_::,
4 £ s:C'sO Q
;35
39
4C
I 397'69
9t33808
STD5¢1537
S.1
.o{]_r?,_
2
4
44
;_5
<t21
6855M
:;l
OT_sZ
Z.........
Q4._-
-_
n@ Std _}ac}<
L_
£'{IA
;,1i%(:.............
i[d.
"......
hxIe[_ee©
1:_&F7[{(f
....
VI3S:.se_ L 0ci< r-i _ ;-ii N 711.b { PI7
..=_
,.+.,:o_e S7L.T _}'Y
_}ckr_.i Fiag
5,8-1" ;INS
Shaft As? ......
q_-' Y'TvS......
_ .sC.,:
0Vasp_er
5! 5x JSO)
SuSmoH Staff
,_VasNer
'4 ;', :so .,. u£
Screw 7-+_u:,
So/?_(e+ iiz'. ;7{0 , L 77
Shaft Asm Pktmar_
Bracket Steerin
........ bin Rod
-s_:_r Sector
-'_,_e
......._..;K 7i-!! ,. 6_1_
Screw Thdro
...................
Pn oot_e t 18 ( ,:,:._
"_"" ikii
:-_0d Tie We
F:orm i915
Bushmo R,-_ 5/8 "_._Das"
S
crew TT s_-,n q't'h,,_£ ,'_iS i" 8 r:;e
__se_ Cap Strg WBee S!_':;B<
145054
i 21749X
..........
!bo/_;U
$7
Steer
9172591"70
8pind e Asrn
5_indie Asm }_\i}
3ea_{n9 Race Thrust barq£
,_
Masi_er 26;;?
X
%/8 ;1 611"
%Jashei
:4
" $
L .}}
mn_'_
, #t5304- 7{i
...........
S
59
s { 4779
HUMBER
q4
£3
73680600
:;;4- ....4 ................
Cbb4J
62
i56594
:%
c7 %598710
65
i " _.... '
7
I ;cs. x _',
57
:=4.78'I 044
68
i54429
69
160367
70
)>4780636
Washer _a'_°
,_,,._z.X 23/8 ,,.
"" A O <_
_u'_Lock "-'"_
÷a "-L't
2 ":bNF
Adaptor Whee qtr,_
3
Boot Shaft Steering
Washer 2 _/,so
_,_ X t I/4 X i6 Gs_.
Extensio
Steering Non-Ad .s_
Cap S)nde
Fr Top B,k
Fitting Grease
Nut Lock Hex Wilns 5/I_ --!8 t. !'--C
NU
,_-......
_;W
Ou_,
,"- 318-i b" UI]C
Boit Fi_ Hex 51111- 18 _.,_L.,.......
11 -;
}(it, Steernq _,s_ernNy
" -'
,'"'
Beaqng Arm Pittman
Bolt F'] Hex %8- ! 'LJlI\ 4_..J
.........
)<,
Axle Brace
Spacer, Brace Axie
7}oit, Fn Uiex 318- 6 L}nc x 2- i 4
..,_,.,=_s....
,_,,t.,,x_w,,. dimensions
•t nnh
7!54 mm
39
giv_-n n LIS.
inc)nes
/
t
sl
\
\
REPAIR
TRACTOR
KEY
i
° ° t !ODEL
NUMBER
917.259t70
PART
i 'i" 1'"-_q
L,i
v,_
1os_%
.....
Thor Pad< e8,%,'_:<:
:},c
£-w >ex Y}-c ,/£_i
! :-2£x5/{_
"
e }..÷e _::geaKqown) :':
,_..........
_._at:
vL e} ,,. 42E71}7 . 8{}:o.#:
>
_UTX%:"
L: !"a xb
Y:xsasst
:,sin ..eExha si._:sm
OaST; " ._)e)"u6
..........
: IR_%
30 :;i{
::; :[',C:: ;< ......
-_¢at ..:bed
L:
:¢_£i_£! ..1;8':: {V _. '_- i:;£-i
:!
lot _', r--e;
42
':7 1:_
S_ :>. _C; K :cv? ° OOi1 }:.
}:;e>,
3i:_-i@x:
1,2 7
;/ ::'<_ro
'o'-;e
N._;.
Keps 3/8-2 ,-: J3f
{:{crew Y- ::i '}.-{}2 x 1:}>: {_/": _-:8"_Ge
_wresior _::,
P_:}"
_;*'
a _!-¢
F e 350 b{ea_
(as
Fie GuagGSTL-:
_'.am_ :--9;,se :Nk
:i:?ac<,P _ ::!
:::k,-._,::.
'r-.-_-_-:
5/! <q-:7 :{L,4 T'rr
L. q:'_ i:,..ql
;::1
7}Fair}{Order ,mr,_,,,,"'-"
7:,..,.:_,>:.
,::.,_,
i._23:..39
40
09227X
3645J
P;_C :diet _ 7;_
........
, X .IT_
..... ,,
,., .06
4"
'1_OOw'r'
L1
128861
Stem Tank FJei
:,,-_..,+ b"-'
{{:hO{1i,{" ,_
.,_."_<.v_
.?r_
Sta:i3o _ :.,t
A: comso,qerst
,rm_
"
:'::
,+
,
c__h,:_.ns!oris
. _r_it: L..S. -'_ ",,-' k_ch = 25.4 :nrr
41
REPAIR PARTS
TRACTOR
_-AT
o ° MODEL NUr BER
917.259170
ASSE_IBLY
.......
<_ijjJ
I-!0
....
......_i I
1111<27.
.....
24 \
\,
-%
26,
¢c__I--i 5
\
\%
23
---1
h
\
KEY
NO.
PART
NO.
I
140123
2 1.05ot
3 STD5237!0
4. 19131610
5 145006
6 STD541437
7 124t81X
8 17490616
9 19131614
10 155925
12 !21246X
i3
121248X
17
"% "<.>_
I
".
d_ j
.--4
12
DESCRiPTiON
Seat
Bracket Pnt Pivot Seat (blk)
Bolt Fin Hex 3/8-!6 UNC x 1
Washer Fiat 13/32 x 1 x 10 Ga
Clip Push-in
Nut Lock Hex W/Ins 3/8 -16 UNC
Spring Seat Cprsn 2 250 Btk Zi
Screw 3/8-16xl
Washer 13/32 x 1 x t4 Ga
Pan Pnt Seat (blk)
Bracket Pnt Mounting Switch
Bushing Snap BIk Nyl 50 Id
KEY
NO.
PART
NO,
t4
15
16
!7
21
22
23
24
25
26
72050411
134300
121250X
123976X
153236
STD54t431
74780814
19171912
127018X
STD551150
DESCRIPTION
Bolt Rdhd Sht Nk 1/4-20xl-3/8
Spacer Split 28 X 96 Zinc
Spring Cprsn 1 27 BIk Pnt
Nut Lock 1/4 Lge Fig Gr 5 Zinc
Bolt Shoulder 5/16-18 Unc
Nut Lock Hex W/Ins 5/16-! 8
Bolt Fin Hex 1/2-13 X 7/8 Gr 5
Washer 17/32 X 1-3/16 X 12 Ga
Bolt Shoulder 5/16-18 X 62
Washer Lock Hvy HIcl Spr 1/2
NOTE: All component dimensions given in U.S. inches
! inch = 25,4 mm
42
RE
tR
TRACTOR
- - '!ODEL
NUMBER
7.259t 70
o
9
/
;3
_4
!
KEY
NO.
1
2
3
J5
6
7
9
i0
1i
18
£EY
HO.
PART
NO.
155489
156810
151299
iO _oOu
273503
133644
180927
148709
150383
156811
146046
WHEELS
Deca
Deca
Deca
Decai
L}ecat
Decai
Decai
Decal
Decal
Deca
==._ ........
Ferder ©_nge: Set's
Fend Ats:o Sea_s God
Hoot;: Fk_ C:afisma
Hood L _ Gaffssan
Ersg{<e 6!>&S
Mast Customer Sea_s L}o;s
Pane Side B&S5
Fender C aftsmas Go:;
Cap CNSMR Hep kme _7_i:::i!i:
Fender STLTH Oser _st £:8
_
,J
;
[,
.
,.,=i
£,'...
......
_.;._;"
PA_T
NO.
_s
i47138
_5
136832
17
_£ os
19
i38047
2O
156787
22
'1495"18
-138811
-142341
.... 154515
--.
154516
-158489
o158490
Decal Chassis Hydro 42"
Decai Mower Drive Schematic
Decal insed Hood
Decai Batteq/Diehard
Sears
Decai Deck Mower EZ3 Mulching
Decat Battery
Deca! Lift Handte
_e_.a,, Drawbar CntrL Mvt H,,_ Lt
Pad Footrest Lh STLT
Pad Footrest Rh SYLT
Manual_ OwneCs (English)
Manuai, OwneCs (Spanish)
_<:Pif
x_J.
DESCRIPTION
59 ! 92
65! 39
4,
5990,1] u©
8
9
10
7152J
4
/
Ide:O/A
/
_
43
_",_
: ,.S_/\%£
:&VSP
9040H
106t 08X427
/
:/
PARS"
SO,
i
2
5
6
9 r_
gC,
/
_ s;_.oRIPTION
,i__
/
Valve Cap, Tire
Stem. Valve
Font
Tube, Front Tire
Not Prov ded, Service Item Only)
Rm. Front
Fitting Grease (Front Wheel Oniy)
Bearng Flange (Front Wheel Only)
Rim_ Rear
Tire, Rear
Tube, Rear Tire
(Not Provided, Service Hem Only)
Cap, Axte
Sealant, Tire (10 oz. Tube)
All component dimensions given in U. S. inches
1 inch = 25.4 mm
REPAIR PARTS
TRACTOR
MOWER
o o MODEL NUMBER
917.259170
LI_
28
27
25 24
7
/
/
/
//
//
/
49
/
/
,/
/
/7
/ !J
/
/
i/
i'
//
"-
/
//
3
/
/
I
/
I
/
13
20
13
20
161718
3!
32
t9
15
32
ztzt
REPAIR PARTS
TRACTOR
MOWER
° o BIODEL NLII"4BBR 9t" .259.70
t
LI_T
;
C 2_eq:, L
4 4 Q 4 _"
'/T:: ,.x_,£_y_ ;::t¢'!r; _;:;[iP_C ,':::!_qi"
S h ::ft ,;:,':._: .... i
::
:XtT£TX
..... .
?2" : {::2
2': S3 X
:::
2231:Y:
" "7986_:7
QA:
:%
......... 272 ! :}
':::
7: 3:1708(0
:
":12¢::
:{ 4:,,_:_5133-'[2
,_:_ste:
27'32 x : x 2'
iPv[r {7
£4
25
:_6
......
-_g:ix t::R"
' ; J':_ :Hex
LOCK
I }807)<
1913!0-;
2S:: } A
8TD56090,7
.g:
..,.f,
} r_dt
29
138057
,,,.
I SU2OO
_
........
23 ::
!{uric " i: .pc,:: ::-_-:_-,:_
. r_-_.ift Lh !:: xec
"_, Xft Rh _"" " "'
..... U Y OS £
P
:.:
3
{Z'._nc
W_i,%III]
:'rm Suspensio_
;: etai_e Scribe
qlt Sp_rc
4/_
,,::tc_..:r",r:s_
i ,:_.,_
Oi
;)
1 O-i.
Li _ ]
Rer
........ X
X 3/5
:::}_
Pn cotter o,_-.
cA./ )"fi 2
_£od i:'di _ft
t. ut Hex J F t;_ -_,:-,
Kisob _
.7i8- i 6
_ .......
s !r_fin Heicnt
JOLj_C
32
tq_x_
;-:m
: -st145 >}'(
AOI';
Nx. Crowntock
318-24Nit !:iange Lock
Nut PJsh Phos & 0ii
NOTE: Ail ....m!ss
_'-' , ._._
.......pt. dimensions a v_n
......in Li.S i-_c_es
i _nch _,.-,
25.4 mrs
REPAIR PARTS
TRACTOR
-o MODEL NUMBER
917.25!i!170
IVtOWER DECK
75
77
73
72
43
105 i
I06_
\
21
27
17
46
RACTOR
_<E Y
.}
i b()8;_2
. }
£.+'
;'J
})_;Ci AsseTr,i) '
_, ;%CRQi
,:;d-:b:
@ia,/ie t 3p
A< "(
:
i 41 :}229
• ........2i _'=" t
::......
÷..........
sic,.:"- ;1[<
3282:7
:1{) "_:
36 }8 _}"
C'_Piq.
; i
_c>**xt31
........
?s
pl
c_ ,!
" i
i"'=i;ic.:!::,
!:!_elrly
1. i:_ !f:!!
{ ;i}
, : i:@ 7Dr
i
i}:,Fc':
!'<d:
tC t fii'<h
;/
O ;w-e
<{tt<}:
!;!e>>c <-:,:,.it <de',
::£t C::'
;;: _!divic,<'
_;,',.i_" f;;
*s_qm
q%:,.
1:.,
__,ei'[
6oit i£bou d_ t
Baffle. it!e)<
*',._+(;cwnock
c
=
,
i
:1<!
.
:z::
< _;;,
G;:
......
"!
-,,
3TD=>t
o ....
2":!
29
,.,
31
191110111
.....1_""
o / 72£
29_63a
V4astte
i 1'32 >::5/8
Rod. Hnge
{}4
OT[h£
,.::,c_
8@
,_/
40
,
.! i
43
Io38_1o
18_ 494
STDoo t03 /
'-'_I ....
_ I 4,o1'_-'°
_;
L.}C,_-_
1335S 1
i _,no-_
_%
,-],-_
46
41;
46
49
c.<,
STD624003
I 3-729
133944
155066
}d d4_
q _<7"_ '?
c_
Screw
T],<
....<._.I _-i
I
.UI
I.
_A
_,ci-_.:_.
_
._,..,
_-_ieat
;1,_"
LOCK
....
_.,ra_i,+t,
=*,.?
I L.;_.4+
"q .::°_ I 0bU4
, 37644
IJo9o1
....
, _9300,_,;>
_v.q
c'wm__
Oq-x
i ..... "='"
i/
I
£,J_=<
J
,.3,{
i!
4"_W
" %.';_ ©
30
87[}'5233
(
[i)
-sin',_ t.}..
0
.8
s/i
O.L>.
--_":_.
3£
i :,"_,L._U,
....
130794
i4541t
U{
._'q2 i 39888
5,._- i33943
.........
s0_6
-='
I 9QMIO'_
i-win i%s, embh?, F>sd, Brake
Washe_ _ Hardened
,o
A_ .... _,_ Retaine-
-
iq
t;i,nter@%
/_it
<
: =;: .u_ component
H
Gauge,
Scew. Thdroi 5,,16 -!8 x 3/4
Nut. Hex Keps 5/!6-18
UNC
-'+
Camaae.. 5/16 UNC x i/2
B@_ Shoutder
Wheel, Gauge
Nut, Oenteflock
3/8-16
Washe_ 318 x 7!8 x !4 Ga
B_ac_<et0 Extruded Gauge Whee
Washer Fe!t
Washer 13,,3=
' " x 13116 x i2 r:_.-,
,_=_.=
Bit Fin Hex 3/8-16 UNC x I G:S
Bolt Rdhd Sqnk 3/8-I6
UNC x i
tdI_£
Spacer,e_'_ v,_SReY
"
_,a9 i.D. X i 3i8
"_ _-" A" 114
<,,._,
,
Manarei Assembly
(Includes
F{e',i
N_.;mbers 8-t0, 12-15, 31 and "o31
"'
Mower Deck, Compiete
(Standard Deck; Order Mulcher
Pate and Gauge Wheel
c,omponems
SeparatelyKey
Nos. 101-106, !11-1t9,
!2i)
@menstons
' :=: =S,
os
d _ .:_iff'I
', " NCK]
S7
Ri
'q t Wed
Bracket _a_u
_....... e Wheel
1
7
•;i 8
19
2!
-
.ILIZ"
E,
?0
I.....
t <
3<
Clime<
}<eeDeN <.:!t !(qe"
:-'-fit ,qmhI oc
....
'-..... 3/8-I _%C nc )<'2-'i i=z
....
=,, ........ NseN
Mulcher c,.t,..
Screw
,Yahe
#I0
VYashe< Lock
! ![_19-7
! 5i'_6
i_÷
VVaaheR Spacer
PuJ_w Mandrel
Nu,Flanged,
t
+4_f-,.
_,.=n_u;,
m = .
9'i8
Bolt
Fastne< ("_",,_
,::,_"+__
.......
,_x>"t>s_,,'_
Pulley, die< Fat
Washer
_ 3,0)4
'.......>. .,_
_ '_#,,
_o v i ""
o Liktugo
Nut, CrowtAock
Rod, l-_iVO[,
" .... ,-=
*'_
..........
i%I[}L
_od, CIutch ,..<,.,..
<,..... '_'"'_*_i
+,,=<x,
,,, v'ith i]ib t,
Guard, Mandre:. _ ......
Retaicer
ScH_.v>flex Hd ' ...... 1 4-].:0 ;<5!
Washe*
Hardened
Roler AssemNy
Cam
Bolt, Sho@de_
_"_._
_
_,• 0;.;:<;:race
"'_: ....
i:i
-,::_
/
11i
i12
i6 IIW,__
I ,
'--ieR,
/asimf,
t0A" r', £
37%,55"1'0
.4_.
i ;4
11 .....
[]c i O'
_
t )
!
104
ie'tt<
hit
<s
j q;;l
P[Ir%a[?
v. v,-,t PhilO<
s
[1[i+ii= g_
<'¢£4
'} i
_-,
;" _ PuS
137266
i = ,;;<-.}
g =
w
}!:i,JCnlNq
5/i6-8
i O_OZ,
-_or'.O_p
% _eh
is: hi, Ext_-_sion. Reum
-_-i
s
: <"L ._ u_CR Seco]<]ayy
:i<s<_e
25/32 x -../®
,:<o x i6 <sau.':le
"
ig
.
.................
- ....... ii:osde
38 i6:
_.o X 4!<@ei:%[
<p i_r
iF<) CI.iTQH, dl-r_r,
Z79
--: ({£'-"
. 0/; :!.
2095 S}'1
i
t
_ z o,
,:;
, o
.....
) c_._Ke . [})e
TrL_--_;,_
/
-ii
12110!i°1!9
(
28902
....... 12-" Ss S
......... :5.-.L:0;,
'<{
i;;}t;]5
CaD 3hse
_;b
" , * {!R A;X:
Siring
Yorsion, B_ake
Gua'd, Idler
'_<'lOb <. StOr_" uu_:_
'iB=:.t....
2 '='_4uwe
.....
"
1187M
.........
;
£7847
:"
iii
"tAYrSe
O08 C
0.?
.... it@s]
:
>+ / b©
1:31267
" ......
r, _" i
SOr
:,gw
:
_g
{{OAFS etsc3
'!S
<....
:
Svva: :ii:-_
4.£
[J}eci
L!.oI 3i8-24X-i.2L
; z(} 21i::{
s{
" x9895
3134{}
%<'
Bit
.-. T!
{}-....
" %;
91%£59t70
C,ART
•
....
_'
<
iU qBER
P _k_'T
A :(:93
{-3 {f 3310>
i 3801
i 38x._-0
ii
V!O©EL
given _n U.,_.. inches
TRACTOR
HYDRO
GEAR TRANSAXLE
o o MODEL
o f4ODEL
NUMBER
NU#BER
9!7,259170
310o0650
135
/t/-...
j
37.
-...
140 "".
34
17
<"
14
\
\
9!
7
4
5
24
11
I
35
! {}F; :x L':) -
x[r
REPAIR PARTS
TRACTOR
BRIGGS
& STRA_ON
ENGINE
o o MODEL
o MODEL
NUMBER
917,259170
NUMBER
42E707,
_68_
_ _ss
_¢PE
NUMBER
1831-A1
615 @
24
634A @
552A
819
41
34
615 @
552
,,_
45
220 @
12
230
534
46 o&,:(
219
_
1_5
!
32
535
445
284
235
I
525
240
524
0
537
5O
REPAtR
R?S
, RACTOR
[_4ODEL NUk_BER
917o259170
?
L:L_ik ::iASKET
851 PtJMR
SE°i
L
_',?t
---_
_;:t
}:;..'
! _
t x_;c[
........ < .....
ii
:%d
..........
v-* _='] OF_ _'(.i i
®
_5
r
.........
;:LL [;S
i
61. ""
i;i5i!
;;;
-
i[
d:_:......
.
t
-,
}I ':-"....
.......... _
I
_9
i _ (.![;41
",Ui '(_
_%It;
t_!
52:
,]92
=...........
,80_<.
......
_
-)-]z]"
]
4_$1
,*_ 188
i 80q
8©1
383
i
" "<"
_:;]:i[;i081"
= .€=._ ,._
"o
51
"
REPAIR PARTS
TRACTOR
BRIGGS
& STRA_ON
ENGINE
_ o _ODEL
o MODEL
NUMBER
NUMBER
917o259170
42E707_ _IPE
NUB,_BER 183toAI
801
783
\
311
201
209A
209
307
_4
4t4
207
EPA[R
PARTS
_AC©D
o _ V!ODEL
......
_U_BER
9!7o259170
,,÷z_7O_ s°v[s_ NU_IBER
t83!oA1
_881
2-
10SS
9 LABE£
K_T!
>_:" EQUtR_S SP£ B_AL TOOLS
/
305
_73
S08_
307
_0_
_'_
2:
REPAIR
TRACTOR
BRJGGS & STRA_ON
KEY PART
NO. NO.
1
2
3
5
5A
7
7A
S
8A
9
10
i0A
!I
12
13
15
16
20
22
23
24
25
26
27
28
29
32
33
34
35
36
40
41
42
45
46
50
51
51A
52
53
497074
399265
391086
493304
493457
493458
271867
271868
495754
222892
27803
94.382
9483O
280225
273208
271188
271189
94565
94239
394028
94196
291675
94724
491180
222698
498584
498585
498586
498587
394959
394960
394961
394962
263129
498319
391286
394306
39"7168
94671
390420
261528
65906
26828
221596
292260
494553
261368
214484
21329O
271412
281411
270884
93970
ENGINE
o o MODEL NUMBER
o _JIODEL NU#_BER 42E707,
917.259170
TYPE NUMBER
KEY PART
NOo NOo
DESCRIPTION
Cylinder Assembly
Sea_, Oil
Sump, Engine
Head, Cytinder #I
Head, Cylinder #2
* Gasket, Cylinder Head #!
* Gasket, Cyiinder Head #2
Breather Assembiy #I
Cover, Bre_th_.
_r Cvhnaer
_ - , #z_
(Used Only on Key #572.
Air Baffle with Holes for Mounting)
* Gasket, Breather
Screw_ Sems
Screw, Sems
Tube, Breather
._._
* Gasket C_anKc_e..015"
Thick
Gasket_ Crankcase, .005" Thick
* Gasket, Crankcase, .009" Thick
Screw, Cylinder Head
Plug, Oil Drain
Crankshaft
Timing Gear Key
* Seal, Oil
Screw, Sems
Flywhee!
Key, Flywheel
Piston Assembly, Standard Size
Piston Assembly, _010" Oversize
Pston Assembly, .020" Oversize
Piston Assembly, .030" Oversize
Ring Set, Standard Size
Ring Set, .010" Oversize
Ring Set, .020" Oversize
Ring Set, .030" Oversize
Lock, Piston Pin
Pin Piston, Standard Size
Pin, Piston, .005" Oversize
Rod, Connecting, Standard Size
Rod, Connecting, .020 '° Undersize
Screw, Connecting Rod
Valve, Exhaust
Valve, Intake
Spring, Valve, Intake
Spring, Valve, Exhaust
Retainer, Valve, Intake
Retainer, Valve, Exhaust
Keeper Valve
Tappet, Valve
Gear, Cam
Manifold, Intake
Gasket, Carburetor Mounting
Spacer, Carburetor
Gasket, Intake Manifold Mounting
Screw, Hex Head,
Carburetor to Manifold
54
75
78
90
9t
93
94
95
96
97
98
_:_e
02
._,0q
"_
104
05
_07
108
109
_:t6
117
93208
22251t
95039
499169
499281
231209
491538
93499
221939
392672
91920
26157
271607
29851
231435
,,_
_.s
q_'z_
..........
491543
_0<_-7,_
392673
280474
232018
232022
t 19
I21
127
!61
185
I87
188
201
202
203
206
207
205
209
209A
219
219A
220
222
224
94152
491539
223472
496599
94.289
299146
94627
262683
262684
280997
94298
262337
93971
262352
261563
394348
393415
222773
491282
94297
*
**
***
1831-A1
DESCRIPTION
Screw, Phi/lips
Washer, Spring
Screw, Hex
Carburetor
BodyAssembty, Upper
Bushing, Throttle Shaft
** Vaive idle Adjust
Screw Seres
Valve, Throttle
Shaft. Throttle
Screw, FHister Head
orinqo _" ..... Adjust
** Gasket, Ca_uretor Body
_
_o_t, Carburetor
** Pin Float Hinge
Valve, Needle
Body Assembly. Lower
Valve Choke
Shaft, Choke
* CoRing
Je_.
+ Needte Valve, Fixed
Jet, Needle Valve, Fixed,
High Altitude
Screw, Hex Head
Carburetor Kit
** Plug, Welch
Base, Air Cleaner
NuL Wing
Line, Fuel, 28" Long (Cut to Suit)
Screw
Link
Link
Crank, Bell
Nut
Spring, Control Rod
Screw, Hex Head
Spring, Governor
Spring, Governor Idle
Gear, Governor
Oil Slinger
Washer, Thrust
Bracket, Control
Screw, Torx®
IncJuded in Gasket Set (495868)
Included in Carburetor Kit (491539)
included in Carburetor Kit (491539),
and Pump Repair Kit (393397)
....
Included in Gasket Set (495868),
and Carburetor Kit (491539)
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
54
sL]O.
............
qsd"
d21 F£_
£S
££33882
..... 92S995
:} _} 39xi3F
,J:
230' S
:;:)389
::58
4fLi:':3
}}93890
2 c .{}23!;3{S
. ?,,:
C;":
,/i v -; 4_4
(;£
{/'5:-6{
Sd7 :_
(
:,{)
(
: ,:,
() 5, ; U'/;
)0_,
:24,7-u:
/.:0 !'/:. U::4775
30:_ ¢9759{
:} { 0 4({)8
51
,#-,'_:';
--_
J
t )_
-
v_as- i
V she!.
]5:
:. $
:: :_::.F ()
:}0[ i':uC' ;;
L.Lj\i@
;hoe"
: ...:::
Qi:[i
L :'{:W.
L:@_
{
:
:IiL'<:
::Ire
. D;) ''I
--i i L:::i
....
+ ,o
_77}:
_
"
}-::,/,(
:C i!v,
:::vd :_
:::,,. (:.
...........
..:_ucs
o(r
St/:_rte_
_o,,:.
.-r-
}:
](7
tJ_
:::0_
Yff.
i:ir si] ]}e:
P,:st He:,:
h-
1!34, 94i31
£_:IL
G
b 2:_" {'[
_TSC2L
f:!{:i5
<_,._o
!){1 4.._i 85£"
3113 19203
'S !;)":!
....
. h£d
+' '_
..,....
d
L::ts
o,
1801 7
.-(
O.'s
_'_51 "s}O£
394
41 i
i_70988
220680
:i-......
]:J
"-_0_" 7_O
.-';'__=,,.o,
4S2
4:14
4A5
.......
22: $77
223588
-,-,,.
_:}d
o ,,r,4 _:4
4.68
:174.
4.82
d.i 0
/_csvoOl:
:98,'-7/9 _}2i
497506
?A
x _
4 "7
.;+Sz_9_
t
525
95S4.8
t!}o _)
m #sm o -
8tdO©
:.JY
:};.()y:gmd ::T.:)FII(. 1!: :i}
}_)/,
£>:;
el:
0
/1134- 9482S
_'535
:':5:190
:.:1
& : Z7 -:,L: '
:::4z].
r --£"
1])© =:::
_ O_-1.O,D_.
<:
L
ssRet
Set
7Q_6 _
:i'i_e_sch.
"° .......
....
bO,,s
i-_O(Jy, PIJrOD
:"_' ' OiaDh[aqY_
if:,t
LQx
ss
_:
_','8_S[ L;"
i_-acKet i)il Fiii
C_:4:, :3t ir:_._
CeveE. 938oht-sc x
b]Few,
L./8[;),iqYe(]']]
{
ii@'
1: P_'_ ,&iI
:£_c_ee :,, _otati:',,,
A ternatc,*
tcscfev,q
Drve, Sta_e_
r,;-,o-_q! Fil
Seat, FI Tube
7ube, OiiFciiliinc;
ces
Hose. '_-..........
iC[J LI
.m_
-
11![ 411]
b
4959(5
_e_
}97E
iO0[
2_t05]
;L_
22490
-"
s96726
05E
272"12
_ s s
k..,i _: L} [ i
ncluce-s
Ftteh
Gaske, A_r .}ieat_
Am_atu e, cOt_i ...>ss_
L_owe["i:bus qnc. :}::..,e.."::: ,
_"
JH__
5bc
, ;_wbi_'e,'e"
!<it !'4.91539'
:;.Ja z_.] ,-(3atr}u_'etor Kit [491539..
:dsc _-..tb-:[ _¢99A_"54; ,39y[.89-7_
:5 LISP,! n C, i}; 11)*,_:!.' '_ :3
....
..........
md ' ..............
,,
/
(('}_ S__, Q ,_
iq15 qc
•_..__;. Ali co; -_pc,.nent dimensions
1 .pch = 25,4 mm
55
given in U.S. inches
E
SEBV_CE
SE
CE
_A
SUGGESTED
GUm[)E FOR S_GHTING SLOPES
FOR SAFE OPERATION
ONLY R_DE UP AND DOWN H_LL_
NOT ACROSS H_LL
S_GHTING
GUIDE
SIGHT AND HOLD TH_S LEVEL WtlH
SKY LtNE OR TREE,
E
P_ODEL NOo
917 _=_ 7 0
_F YOU NEED
REPAIR SERVICE
OR PARTS:
FOR REPAIR SBRV!CE CALL
TH_S TOLL FREE NUMBER:
1oS00o4°REPA_R
19,5 HP
ELECTRIC START
42" MOWER
HYDROSTATIC
LAWN TRACTOR
Each tractor .ha=.,
., its w_""modei
is own modei numbe.
number.
Each er_qme_,has
The mode number for your tractor
modet piate iocated under the seat.
wifi be
n_:, mode number for u_,
bower hOUsing of the engine.
wiii be __' _'_
endine
_.,u, u .,,, the
£ Darts isted
herein may se ordered
from _::ry Sea:m:
Roebuck and Co Service Ce ter/Department
_<nd most Re-_a Stores.
WHEN ORDERING REPAR PARTS, ALWAYS
FOLLOWING INFORMATION:
G_VE THE
PRODUCT - TRACTOR
o _qODEL NUMBER - 9t7.259170
o ENGINE MODEL NO. - 42E707-1831°AI
o PART NUMBER
FOR REPLACEMENT
PARTS
NFORMATiON
AND
ORDERING, CALL THiS
TOLL FREE NUMBER:
t °800o,FON°PART
o PART DESCRIPTION
Your Sears merchandise has added vaiue when you
consider Sears has service units nationwde staffed with
Sears trained technicians..,
professionai
technicians
specifically trained to insure that we meet our pledge to
you, we service what we seli_
FOR CONSUMER
ASSISTANCE
HOT LiNE CALL THIS
TOLL FREE NUMBER:
Io800o659o5917
158489
4.9.97
RH
Printed
in U.S.A.