Download MCE-525UR - Fixmag.ru
Transcript
MCE-525UR Page TECHNIC AL SPECIF ICATIONS.. .......................................1-2 MEASUR EMENT SETUP............ .......................................1-3 SERVICE AIDS, SAFE TY INSTRU CTION, ETC ..........1-4 t o 1-5 PREPAR ATIONS & CO NTROLS... .................. .........1-6 to 1-10 MAINTEN ANCE & TR OUBLESHO OTING ....... .................. 1-11 DISMANTLING INSTR UCTIONS . ..........................................2 SET BLO CK DIAGRAM ................ .................. .................. .....3 SET WIR ING DIAGRA M ............... .................. .................. .....4 KEY BOARD ............ .................. .................. .................. ..... 5 SERVO B OARD .................................................................. 6 MAIN BO ARD .......... .................. .................. .................. ..... 7 SET MEC HANICAL EXPLODED VIEW & PART S LIST ............ 8 Components General Power supply: Maximum power output: Suitable speaker impedance: Suitable speaker power: Pre-Amp output voltage: Fuse: Dimensions(WxHxD) Weight: Aux-in level: Sub-woofer output voltage: 12V DC(11V-16V) Test voltage 14.4V, negative ground 55Wx4 channels 4-8 ohm 80-100 Wx4 channels 4.0V ( CD play mode: 1KHz, 0 dB, 10 KΩ load ) 15A 178x50x166mm 1.64kg ≥300mV 4.0V Mounting collar Machine screws M5x6 mm M4x6 mm Mounting bolt (50 mm) Wire connector Case for removable control panel Trim plate T-key User manual Rubber cushion Remote controller(optional) FM Stereo Radio Frequency range: Sensitivity: Frequency response: Stereo separation: Image response ratio: IF response ratio: Signal/noise ratio 87.5 - 108.0 Mhz (Europe mode) 87.5 - 107.9 Mhz (USA mode) 65.0 - 74.0 MHz ( OIRT mode ) 10 dBμ 30 Hz-15KHz 30dB(1KHz ) 50dB 70dB 55dB AM(MW) Radio Frequency range: Sensitivity(S/N=20dB): 522-1620 khz (Europe mode) 530-1710 khz (USA mode) 30 dBμ Disc Player System: Frequency response: Signal/noise ratio: Total harmonic distortion: Channel separation: ESP: Disc digital audio system 20 Hz - 20KHz >80 dB Less than 0.20%(1 KHz) >60 dB CD≥12s, MP3 ≥45s Note: Specifications and design are subject to change without notice for product improvements. 1 4 4 1 1 1 1 2 1 1 1 Wiring Diagram Aux-in Black R ( Red ) L ( White ) Antenna Fuse 15A AUDIO OUT Am plifier (Green) Subwoofer out Connector R(Red) Rear Line-out (Gray) L(White) Front Line-out (Brown) R(Red) Amplifier Amplifier L(White) ISO Connector Red Ignition key +12V DC When ON/ACC Black Ground Lead Blue Motor/Electric Antenna relay control Lead Amplifier relay control Lead To car battery(+) Continuous +12V DC Yellow Pink Purple Purple/ Black Stripe Gray Gray/ Black Stripe White/ Black Stripe White Green/ Black Stripe Telephone Mute (active low logic level)(optional) For some VW/Au di or Op el(Vau xhall) car model s, you may ne ed to m odify wir ing of the supplied po wer co rd as illu strated , or els e the m emory of the uni t may b e lost af ter you powe r off. Co ntact y our auth orized car de aler be fore ins talling this uni t. Origin al wirin g Green Yellow Yellow Red Red Modified wir ing Right Speaker (Rear) Right Speaker (Front) Left Speaker (Front) Left Speaker (Rear) Yellow Yellow Red Red Using the ISO Connector 1.If your car is equipped with the ISO connector, then connect the ISO connectors as illustrated. 2. For connections without the ISO connectors, check the wiring in the vehicle carefully before connecting, incorrect connection may cause serious damage to this unit. Cut the connector, connect the colored leads of the power cord to the car battery, as shown in the colour code table below for speaker and power cable connections Connector Telephone-mute/pink Battery 12V (+)/yellow Auto Antenna/blue ACC+/red Ground/black Connector Rear Right(+)---Purple Rear Right(-)---Purple/Black Stripe Front Right(+)---Gray Front Right(-)---Gray/Black Stripe Front Left(+)---White Front Left((-)---White/Black Stripe Rear Left(+)---Green Rear Left(-)---Green/Black Stripe Radio tune Display switch To fast search within a track/ skip to next or previous track Mute Traffic Announcements Identification Alternative Frequency Radio Disc play (when disc inserted) REG ON/OFF USB-driv e (when USB inserted) Radio local/distan t MEM-card SD/M MC c ard slot (when SD/MMC inserted) CDC changer (optional) USB con nector Aux-in i pod con nec tor Power ON/OFF Rotate the control to adjust volume level Panel Open Push once or more to select VOLUME/BASS/TREBLE/ BALANCE/FADER, Rotate the control to adjust level Remote sensor Push for more than 2 seconds to access MENU function AMS MP3 track / file /character search Radio preset BAND SWITCH Rotate the co ntrol to choose front pane l button illumination color. Press for 0.5 seconds to listen to a preset station. Hold for more than 2 seconds to store station. FM1 FM2 FM3 OIRT AM1 Disc Eject AM2 SEARCH NOTE: Certain tuner button and menu functions e.g. TA, AF, PTY, EON, only operate for users in areas with RDS service reception availability. Disc slot: insert a disc for playback here. RESET HOLE Note: Pressing the RESET hole will erase the clock setting and stored stations. Panel status indicator: Lights up when you slide the panel down; Flashes when you remove the panel. Radio preset scan Radio auto preset MP3 track / file/ character search Di sc Load / Ej ect Load : Press to flip do wn the panel. Eject : Press Radio: To fine tune the radio, press or briefly. To search the station automatically, press or to flip down the panel. Press In sert the di sc into the s lot . to eject the d isc . for more than 0.5 second . Disc Playback: Track skip: press briefly to go to the next or previous track. Track seek: press for more than 0.5 second to seek the forward or previous track. AMS : Auto Memory Store Pres s brief ly to scan the preset station fo r 5 seconds each. Hold for more than 2 seco nds, the 6 stron gest available station wi ll be au tomatically saved in the memo ry of p reset buttons . Viewing Clock Time During Radio/ Disc Playback Press DISP (once for Radio mo de or twice f or othe r modes),di splay s hows the clo ck time after 5 seconds. Setting The Clock Time Press DISP , time displays. Press a gain for more than 2 seconds, time displa y blinks. Rotate the control cloc kwise to set the ho urs or counterclo ckwise to se t the minute s, press DISP again to ex it the clock s etting . Press the rotary volume control for more than 2 seconds to enter the menu mode, then each press changes the mode as follows: TA mode MASK mode RETUNE mode DSP mode LOUD ON / OFF WOOF ON / OFF ESP mode (CD≥12s, Mp3≥45s) COLOR mode LOCAL / DX mode (only in tuner mode) STEREO / MONO mode (only in FM mode) SEEK1/2 mode (only in tuner mode) BEEP ON / OFF MULT ON / OFF TA mode: Rotate the rotary co ntrol t o choo se TA ALARM or TA SEEK . If th e TA (t raffic Announceme nts) function is turned on a nd the re is n o traffi c iden tificati on code received in the s pecifie d time then no TA/TP will be display. TA AL ARM m ode : Alarm is turn ed on . TA SEEK mode: TA SEEK is automatically activated. MA SK mo de: R otate t he con trol to choos e MAS K DPI or MA SK AL L mod e. In s ome c ases, the AF functi on ma y be in fluenc ed by some i nterfe rence, exam ples are signa ls with strong field but without t he RDS data . For th is rea son, th e unit has two optio ns to a void th e abo ve inte rferen ce. MA SK DP I mod e : Only AF w hich h as diff erent progra m iden tificat ion is m aske d. MA SK AL L mod e : The AF wh ich ha s diffe rent p rogram identification and NO R DS sig nal wit h high field s trengt h is ma sked. RETUNE mode: Rotate the control to choose RETUNE-S or RETUNE-L. RETUNE-S or RETUNE-L is time length selection of the TA SEEK retune interval. RETUNE-S: short, TA SEEK retune interval is 45 seconds. RETUNE-L: long, TA SEEK retune interval is 180 seconds. Remark: RETUNE mode functions for TA during TA SEEK mode only. DN V OL UP ESP: 12/45s DSP mode: Rotate the control to choose DSP sound effect: POP ROCK CLASSIC FLAT DSP OFF LOUD mode: Rotate the control to choose loudness on or off. WOOF ON / OFF: Rotate the control to choose Sub-woofer on or off. ESP12:Selected as CD-ESP time 12 seconds. ESP45:Selected as MP3-ESP time 45 seconds. MULT ON / OFF: Multi Session ON/OFF.(Multi session OFF: mixed cd, ONE session CD; Multi session ON: Mixed, Extra, multi session CD) BEEP ON/OFF mode: Rotate the control to choose button beep sound on or off. SEEK 1/2 mode: Rotate the control to choose radio seek mode 1 or 2 . SEEK 1: searching station will stop when next station is received. SEEK 2: searching station will stop when or button is released and next station is received. STEREO/MONO mode: Rotate the control to choose FM stereo or mono. LOCAL/DX mode: Rotate the control to choose tuner sensitivity local or distant. COLOR mode: Rotate the control to choose front panel button illumination color. COLOR 1: Button illumination color is RED. COLOR 2: Button illumination color is GREEN. While playing MP 3 disc/USB/SD/MMC-M P3 M USIC, the folder/file name and ID3 TAG ( Song title, Album and Artist) can scroll entirely across the LCD. (Press the BAND button to show ID3 information) Elapsed playing time & Track number Folder name & number File name & number Song title Album title Artist name MP3 Track search Press AMS to select "TRACK SCH" mode. Press the control and LCD display will show "001". If the desired track number is less than 100, Rotate the control to select the first digit and press the control once again And rotate the control to set the tenth digit of the track number. Press the control again more than 0.5 second to play the track. If the desired track number is more than 100, Rotate the control to select the first digit and press the control to confirm, Rotate the control to select the tenth digit and press the control to confirm, Rotate the control to select the hundredth digit and press the control to confirm, Press the control again to play the track. MP3 File search Press AMS twice to select "FILE SCH" mode. Press the control to enter, Rotate the control to select folder. * If the track number you enter is beyond the maximum file number, the last song will be played. If you just want to play songs from this folder, press the knob for more than 0.5 second to play the first track of the folder. If you want to play a desired track in the folder, press the knob and rotate to select the track you want. Press the knob again to play the track. Press AMS button three times to select "CHAR SCH" mode. Press the control and "A" displayed. If you press the control more than 0.5 second. A track beginning with the letter " A" will be played. If you want to select a track name beginning with a different letter. Rotate the control to select a letter, then press the control to confirm. Then "A" flashes at the next place, select 2nd and other character of the desired track name as steps above. Press the control more than 0.5 second to play your desired track. Example: To search character "ECHO". REMOTE CONTROLS Power On : Press any button on the remote control to turn on the unit. Radio Volum e Power on/off Radio Tune Disc play (whendisc inserted) To fast search within a track/ skip to next or previous track USB-drive (when USB inserted) MEM-card (when SD/MMC inserted) Mute CDC changer (optional) Aux-in Press to select VOLUME/BASS/ TRE BLE/BALANCE/FADER , use Volume button to adjust level Radio Preset scan MUTE Press briefly for Play / Pause function Press for more than 2 seconds if you want to start playback from the beginning of the first track of your disc. Intro play(10sec) SEL AMS MENU Traffic Announcem ents Identifica tion Disc Playback TA MP3 track -10 down MP3 track +10 up Radio Auto Preset 1 /T OP Radio Preset 1 6 SEARCH MP3 track / file/character search SEARCH AF/REG PTY BAND 2 INT 3 RPT 4 RDM 5 6 DISP Track Repeat P lay Track Random Play AMS VOL Press for more than 2 seconds to access MENU function MP3 track /file/character search SRC Band switch FM2 FM3 Display switch Program Type Press to listen to a preset station, Hold for more than 2 seconds to store a station. FM1 Alternative Frequency OIRT AM1 AM2 REG ON/OFF Replacing the lithium battery of remote control unit. * When the op eratio n rang e of th e card remot e control becomes s hort o r no Properly, repla ce the lit hium b attery with a new o ne. M ake sure the battery polarit y repla cement is co rrect. 1. Pull out th e batte ry hol der wh ile pre ssing the sto pper. 2. Inse rt the button -type lithium batte ry with the (+ ) mar k facin g upw ard. In sert th e batt ery ho lder in to the rem ote co ntrol. (CR 2025) WARNINGS: S tore t he bat tery in place where children cannot re ach. I f a chi ld acci dentally swa llows the ba ttery, c onsul t a doc tor im mediately. D o not recha rge, sh ort, disasse mble o r heat the battery o r disp ose it in a fir e. D oing any of these things may c ause the battery to give o ff hea t, crac k or st art a fire. D o not leave the ba ttery w ith other me tallic m ateri als. D oing this ma y cau se the batter y to gi ve off heat, c rack o r start a fire. W hen throwing awa y or saving the battery, wrap it in tape a nd ins ulate; other wise, t he bat tery m ay sta rt to give off heat, c rack o r start a fire. D o not poke t he battery with twe ezers or similar to ols. D oing this ma y cau se the batter y to give off heat, c rack o r start a fire. 1-12 General No power or no sound Car engine switched off. Turn on the car ignition. Cable is not correctly connected. Check connection. Fuse is burnt. Replace fuse. Check volume or mute on / off. If the above solutions cannot help, press the RESET hole. Disc Disc is inserted but no sound. Disc sound skips, tone quality is low. Radio Interference noise during broadcast Station is too far, or signals are too weak. Select other stations of higher signal level. Preset station lost Battery cable is not correctly connected. Connect the battery cable to the live terminal . Error Display Messages Disc is upside down. Place disc right way up, with the label side up. Disc is dirty or damaged Clean disc or change disc. Disc is not CD or contains no MP3 files. Disc is dirty or damaged. Clean CD or change another CD. MP3 error, check the disc. Disc upside down. Recovery error, check the disc. USB/SD/MMC MP3 DATA error. o Sound skips due to vibration. Mounting angle is over 30 . Adjust mounting angle to less than 30o. Unstable mounting. Mount the unit securely with the mounting parts. Disc mechanism error Press to eject the disc. In case that the disc cannot be ejected by pressing , press the RESET switch and press the again. If you are still unable to eject consult your dealer. 2-1 2-1 DISMANTLING INSTRUCTIONS 1 Pull out the short sheet from main set. 2 Remove top and bottom covers. 4 Remove CD loader Remove 2 pcs screw on the top of loader. Loosen 8 screws to remove heatsink & top cover & bottom cover. Remove 6 pcs screw on the main board. 3 Loosen 4 pcs screw to remove Front Cabinet. Remove the 2 pcs screw to dismantle the frame. Remove 2 pcs screw from front cabinet. Remove the screw on the right side of the cabinet. Remove the screw on the left side of the cabinet. Pull out FPC wire. Remove the 2 pcs screw to dismantle the frame. Remove the two connectors from the mainboard. 2 -2 2-2 DISMANTLING INSTRUCTIONS Service Position A Service Position B Service Position C Service Position D 3 SET BLOCK DIAGRAM 3 4 WIRING DIAGRAM 4 5-1 5-1 LCD PIN CONNECTION KEY BOARD TABLE OF CONTENTS LCD Display..........................................................5-1 Front Board...........................................................5-2 Connecto r Board....................................................5-2 Key Board Circuit Diagram......................................5-3 Key Board Layout Diagram.....................................5-4 USB Board ............................................................5-5 Elect rical Parts Li st................................................5-6 PIN SEGMENT DISPLAY 5-2 5-2 FRONT BOARD - CIRCUIT DIAGRAM CONNECTOR BOARD - CIRCUIT DIAGRAM FRONT BOARD - LAYOUT DIAGRAM CONNECTOR BOARD - LAYOUT DIAGRAM 5-3 KEY BOARD - CIRCUIT DIAGRAM 5-3 5-4 KEY BOARD - LAYOUT DIAGRAM TOP VIEW KEY BOARD - LAYOUT DIAGRAM BOTTOM VIEW 5-4 5-5 USB BOARD - CIRCUIT DIAGRAM USB BOARD - LAYOUT DIAGRAM 5-5 5-6 5-6 ELECTRICAL PARTS LIST - KEY BOARD Q TY Part N O. D escri ption 83823 CMU7 06FC000 C MU70 6 FC MI Ass m 1 13300 00100 17 P CB,F B,CMU 501,F R-2,3 8×20× 1.2m m 1 14380 50002 17 C ONNECTO R,14P IN,2.0 mm,SO CKET 1 Lo cation Part NO. Description 1 23805 000016 14PIN,2 .0mm,SOCK ET M ALE ESTF2-14-01 Q TY Lo cation 1 CO N301 IC302 (9 0°) C ON501 F EMAL E EST F2-14 -0, 1 42212 010002 PHOTO DIODE,IRM2,638 AF4,5V/1.1 1 8 3823CMU708SD0 01 CMU708 USD+SD MI Assm 1 1 33010 010308 PCB,MC-USB-SD,CMU705,FR4, 1 12382 50000 98 B AR CON.,14PIN,AWG28 ,50mm ,GRAY 1 83823 CMU7 06LB0 00 C MU70 6 LB M I Ass m 1 13300 00100 29 P CB,L B,CMU 706,9 4V0,1 .2mm, 96.5X24mm 1 12164 00001 02 R CF,1K Ω,±5 %,1/8 W 1 14340 50100 41 L ED,RED,φ3 ,204S RD/E-A,20m A,2.4 V 1 14321 00000 53 TACTS W,DP 1130X ,,PANASONIC 1 SW391 14321 00000 21 TACT S W,TS -03-AS 1 SW393 1 42400 000504 14321 00000 27 TACT S W,TS -06V-A SM 1 SW392 1 42400 000246 14382 5010117 B ARCO N,7P IN,AWG28#, 50mm ,GRAY 1 C ON391 83822 CMU7 05KB000 C MU70 5 KB SMT Assm 14301 00002 18 C ON502 88.3×127.7× 1.2mm 1 21803 000104 CAP,0.1 μF,+8 0%-2 0%,16V,Y5V,0603 2 C9 90~C9 91 R 391 1 42206 000004 REC DIODE,1N4001,1 A,1V,50V,DO- 41 1 D9 91 LE D391 1 22040 000042 CHIP BEAD,0805,2. 0X1.2X0.9X0.5,200mA, 1 L9 90 IC,UTC1117-3.3V,SOT-23 ,UTC 1 IC991 IC,MC7805,TO-220,TI/NATIONAL/KEC/NO-S 1 IC990 1 23800 000050 FFC SOCKET,11PIN,1.25m m,DIP 90° ,UP 1 CO N990 1 1 23800 010043 6PIN,2. 5mm,CONNETOR (90°) 1 CO N401 P CB,K B,CMU 705,F R4,16 2.4×1 67.2× 1.2m m 1 1 23805 000097 6PIN,USB-SOCKET(STANDARD FEM ALE 1 US B901 14240 00003 38 I C,SC7 5823E ,QFP -64-14 X14-0 .8,SL 1 14340 50000 48 L ED,RED/GR EEN, 19-22U RSYG C/S2 52/TR8, 21 LE D1~L ED21 14321 00000 16 TACT S W,KPS-110 7YB-1 30 14220 60000 20 S W DIO DE,1 N4148 ,25mA .0.9V,100V, MINI-M ELF 1 D 301 14222 40000 23 Z ENER DIODE,5V6 ,MINI MELF 1 ZD301 14222 40000 25 Z ENER DIODE,6V8 ,1/2W,±5% ,1206 3 ZD302~ ZD304 12160 60006 81 R ES,6 80Ω,± 5% ,1 /10W,0805 8 R 301~R 304 R 345~R 348 12160 60004 71 R ES,4 70Ω,± 5%,1/10W,0 805 6 R 339~R 344 12160 60001 01 R ES,1 00Ω,± 5%,1/10W,0 805 1 R 312 12160 60008 21 R ES,8 20Ω,± 5%,1/10W,0 805 1 R 349 12160 40000 00 R ES,0 Ω ,±5% ,1/16 W,060 3 1 R 355 12160 40001 01 R ES,1 00Ω,± 5%,1/16W,0 603 2 R 350,R310 12160 40001 02 R ES,1 KΩ,± 5%,1/1 6W,06 03 4 R 317,R331,R358,R3 64 12160 40001 03 R ES,1 0KΩ,± 5%,1 /16W,0 603 1 R 308 12160 40001 52 R ES,1 K5Ω,± 5%,1 /16W,0 603 2 R 318,R332 12160 40001 81 R ES,1 80Ω,± 5%,1/16W,0 603 2 R 325~R 326 12160 40002 20 R ES,2 2Ω,±5 %,1/1 6W,06 03 3 R 305~R 307 12160 40002 21 R ES,2 20Ω,± 5%,1/16W,0 603 2 R 313,R327 12160 40002 22 R ES,2 K2Ω,± 5%,1 /16W,0 603 2 R 319,R333 12160 40002 25 R ES,2 .2MΩ, ±5% , 1/16W,0603 1 R 365 12160 40003 31 R ES,3 30Ω,± 5%,1/16W,0 603 2 R 314,R328 12160 40003 32 R ES,3 K3Ω,± 5%,1 /16W,0 603 2 R 320,R334 12160 40004 71 R ES,4 70Ω,± 5%,1/16W,0 603 2 R 315,R329 12160 40004 72 R ES,4 K7Ω,± 5%,1 /16W,0 603 4 R 321,R335,R357,R3 62 12160 40004 73 R ES,4 7KΩ,± 5%,1 /16W,0 603 6 R 311,R3 52~R 353,R 354,R361,R3 63 12160 40006 81 R ES,6 80Ω,± 5%,1/16W,0 603 2 R 316,R330 12180 30001 02 C AP,1n F,±10 %,16 V,X7R,0603 1 C 302 12180 30001 04 C AP,0. 1μF,+ 80%-2 0%,16V,Y5V,0603 1 C 306 12180 60001 05 C AP,08 05,10 5,50V,Y5V,+ 80%-2 0% 4 C 301,C303~C304,C305 14225 10000 01 T R,2N3904(N PN),S OT- 23 2 Q 301,Q 302 14224 50000 24 T R,KTC8550 S(PNP ),SOT-23 2 Q 303,Q 304 14340 00000 48 L CD,CMU70 5,NEG ATIVE COLO UR 1 LC D301 14340 50000 60 L ED,W HITE, φ3,20 4-15A UWW, 20MA,3.5V 2 LE D301 ~LED302 12166 20000 05 E NCO DER,E CB11( 7X5)( PV)S1 7, 1 EN301 E C110 201M2 D-HA 1-011 CONNECTOR) 90° IC 301 2 5mA,2.4V 17 100MHZ,0.40Ω SW301~ 316,S W318 1 43805 000207 SD/MMC SOCKET-H SMT CMU7 05 1 CA RD90 1 1 21830 000226 E.CAP,2 2μF,± 20% ,4X5,16V,105℃ 3 C9 93~C9 95 6-1 SERVO BOARD TABLE OF CONTENTS Circuit Diagram...................................................................6-2 PCB Layout Top View.........................................................6-3 PCB Layout Bottom View....................................................6-3 Electrical Parts List .............................................................6-4 6-1 6-2 SERVO BOARD - CIRCUIT DIAGRAM 6-2 6-3 SERVO BOARD - LAYOUT DIAGRAM TOP VIEW 6-3 SERVO BOARD - LAYOUT DIAGRAM BOTTOM VIEW 6-4 6-4 ELECTRICAL PARTS LIST - SERVO BOARD Part N O. Des criptio n QT Y Locat ion Part NO. De scription 142400000 504 IC,UTC1117-3. 3V,SO T-23,UTC 1 IC9 07 142400000 339 IC,SDRA M1MX16 HY 57V161610E,TSO P11-5 0, 1 IC9 03 QTY Loc ation 83822 CMU7 06SB002 CMU 706 SB SM T Assm 1 12160 40001 01 RES,100Ω ,±5% ,1/16W,0603 3 R994,R981, R984 12160 40001 02 RES,1KΩ ,±5%, 1/16W,0603 9 R925,R940, R955~ R959 ,R966 ,R993 12160 40001 03 RES,10KΩ ,±5% ,1/16W,060 3 7 R904~R905 , R949 ,R950 ,R946 ,R947 ,R948 142400000 321 IC,S1L92 26,48 -LQFP-0707 ,SAMSUNG 1 IC9 01 12160 40001 04 RES,100K Ω,±5 %,1/16 W,06 03 5 R912,R913, R934, R937, R942 142400000 176 IC,IP400 1D,28 SSOP H/S,INTERP ION 1 IC9 06 12160 40101 05 RES,1MΩ ,±1% ,1/16W,0603 3 R932,R938, R988 142400000 503 IC,TMC5 1FW,4 8-PIN -ETQF P,MU LTMEDIA 1 IC9 05 12160 40001 23 RES,12KΩ ,±5% ,1/16W,060 3 2 R903,R929 142400000 501 IC,S5L83 10W,100-TQ FP-P KG,MULTMEDIA 1 IC9 02 12160 40001 24 RES,120K Ω,±5 %,1/16 W,06 03 1 R979 133010020 419 DS -USB-SB,CM228,FR4,1.2mm, 122X6 7.9mm 1 12160 40001 53 RES,15KΩ ,±5% ,1/16W,060 3 4 R908,R989, R990, R967 121604000 334 RE S,330 KΩ,± 5%,1/ 16W,0 603 2 R92 2,R92 3 12160 40001 54 RES,150K Ω,±5 %,1/16 W,06 03 1 R906 143800000 006 15 PIN,1. 0mm,FPC S OCKET SMT TYPE TOP 1 CN9 02 12160 40001 83 RES,18KΩ ,±5% ,1/16W,060 3 2 R928,R935, (Tem p Sta bility± 100% PPM/℃ ) HY NIX CO NNEC T TYP E 121604000 470 RE S,47Ω ,±5% ,1/16W,060 3 2 R99 1,R99 2 12160 40002 20 RES,22Ω, ±5%,1 /16W,0603 2 R980,R982 121604000 000 RE S,0Ω ,±5%, 1/16W,0603 1 R99 9 12160 40002 21 RES,220Ω ,±5% ,1/16W,0603 2 R933,R936 121604000 681 RE S,680 Ω,±5 %,1/16W,06 03 1 R92 6 12160 40002 22 RES,2K2Ω ,±5% ,1/16W,060 3 5 R961~R965 121803000 470 CA P,47p F,±5% ,16V, NPO,0 603 1 C96 4 12160 40002 23 RES,22KΩ ,±5% ,1/16W,060 3 2 R909,R931 127070010 965 CM V100 ,LASE R WARNING LABE L 1 12160 40002 24 RES,220K Ω,±5 %,1/16 W,06 03 4 R902,R910, R978, R960 121405000 004 20 6,SPO NGE F OR F PC 2 12160 40003 33 RES,33KΩ ,±5% ,1/16W,060 3 1 R911 144840030 017 DE CK,CL-C01FY7(SHINWA) 1 12160 40004 72 RES,4K7Ω ,±5% ,1/16W,060 3 8 R901,R943~ R945 ,R951 ~R954 121040000 186 SC REW, PTS,C olor Z nic,M2 .0X4 4 12160 40004 73 RES,47KΩ ,±5% ,1/16W,060 3 4 R983,R939, R927, R916 121830020 106 E.CAP,10μF,± 20%,4 X5.5, 16V,85 ℃ 3 CE9 03,CE 905,C E906 12160 40006 83 RES,68KΩ ,±5% ,1/16W,060 3 1 R915 121830020 107 E.CAP,100μF,± 20% ,6.3X5 ,16V,1 05℃ 4 CE9 02,CE 907,C E911, CE91 4 12160 60008 20 RES,82Ω, ±5%,1 /10W,0805 1 R924 141830000 475 E.CAP,4.7μF,± 20%, 4X5,1 6V,105 ℃ 3 CE9 01,CE 908,C E909 12160 40008 22 RES,8K2Ω ,±5% ,1/16W,060 3 1 R930 121830040 476 E.CAP,47μF,± 20%,5 X5,16 V,105 ℃ 2 CE9 04,CE 916 12160 40008 23 RES,82KΩ ,±5% ,1/16W,060 3 3 R907,R918, R920 121833000 227 E.CAP,220μF,± 20% ,6.3X7 ,10V,8 5℃ 1 CE9 15 12160 60001 00 RES,10Ω, ±5%,1 /10W,0805 1 R917 143405000 004 INFRARED RE CEIVER,IR9 28-6C 2 LED 901,L ED902 12160 60001 51 RES,150Ω ,±5% ,1/10W,0805 1 R941 142820000 006 CRYSTA L,12.0 MHZ,± 30pp m,-20 ℃~+7 0℃, 1 XT9 91 12161 80002 20 RES,22Ω, 4,±5% ,1/16 W,060 3 4 R995~R998 12180 30001 02 CAP,1nF,± 10%, 16V,X 7R,0603 3 C924,C936, C937 1 XT9 01 12180 30001 22 CAP,1200pF,±1 0%,50 V,X7R ,0603 2 C959,C961 12180 30001 03 CAP,0.01μ F,±1 0%,50 V,X7R ,0603 6 C904~C905 ,C914 ,C928 ,C912 ,C962 143210000 004 DE TECT SW,S W111 1 SW901 12180 30001 04 CAP,0.1μ F,+80% -20% ,16V,Y 5V,06 03 27 C906~C908 ,C910 ,C911 ,C920,C921,C923, C925, 123820010 136 FF C,33P IN,1.2 5mm,100mm 1 C0N 901 C934~C935 ,C948 ~C954 ,C940 ~C945 ,C916 C965 143820010 110 FF C,11PIN,1.2 5mm,2 00mm 1 CON 905 CL =18pF,HC-4 9/US 142820000 008 CRYSTA L,16.9 344MHz,±3 0ppm ,-20℃~ +70℃ , CL =18pF,HC-4 9/US ~C96 6 121830000 226 E.CAP,22μF,± 20%,4 X5,16 V,105 ℃ 1 CE9 18 12180 30000 47 CAP,4.7pF,±0.5 P,50V, NPO,0 603 1 C901 142206000 004 RE C DIO DE,1N 4001,1A,1V,50V,D O-4 1 1 D90 1 12180 30000 82 CAP,8.2pF,±0.5 P,50V, NPO,0 603 1 C902 12180 30001 80 CAP,18pF,±5%, 50V,NPO,06 03 2 C957,C958 12180 30002 22 CAP,2200pF,±1 0%,50 V,X7R ,0603 4 C909,C918, C926, C927 12180 30003 30 CAP,33pF,±5%, 50V,NPO,06 03 2 C938,C939 12180 30003 33 CAP,33nF,±10% ,16V,X 7R,0603 2 C922,C932 12180 30003 91 CAP,390pF,±10 %,50V,X7R,0603 1 C919 12180 30004 74 CAP,0.47u F,+80 -20%,25V,Y5 V,060 3 2 C913,C933 12180 30006 82 CAP,6800pF,±1 0%,50 V,X7R ,0603 1 C903 12180 30006 83 CAP,0.068 μF,± 10%,5 0V,X7 R,060 3 2 C915,C929 12180 30008 21 CAP,0603,820pf ,±10% ,16V, X7R 1 C963 12204 00000 42 CHI P BEAD,080 5,2.0X 1.2X0 .9X0.5 ,200m A, 4 L901, L902,L 904,L 909 100 MHZ,0 .40Ω 14222 40000 21 ZEN ER 1 ZD90 3 14224 50000 20 TR, KRC1 06S( NPN) ,SO T-23 1 Q991 14224 50000 19 TR, KRC1 03S, SOT- 23 7 Q902 ~Q908 14224 50000 24 TR, KTC8 550S( PNP) ,SO T-23 1 Q901 14240 00005 05 IC,UTC111 7-1.8 V,SOT-223,UTC 1 IC908 D IODE ,5V1,1/2W ,MIN I ME LF 7-1 MAIN BOARD TABLE OF CONTENTS Circuit Diagram ................................................................ 7-2 PCB Layout Top View ...................................................... 7-3 PCB Layout Bottom V iew ................................................ 7-4 Electrical Parts List ..... ...... ...... ...... ...... ...... ....7-5 to 7-6 7-1 7-2 MAIN BOARD - CIRCUIT DIAGRAM 7-2 7-3 MAIN BOARD - LAYOUT DIAGRAM TOP VIEW 7-3 7-4 MAIN BOARD - LAYOUT DIAGRAM BOTTOM VIEW 7-4 7-5 7-5 ELECTRICAL PARTS LIST - MAIN BOARD Part N O. Des criptio n Q TY Loc ation Part NO. De script ion QTY Lo cation 83823 CMU7 06MB 113 4X4 V ESP FM/O IRT M B MI Assm 1 113850000028 ∮ 0.5mm ,24mm 12183 00001 05 E.CAP,1μ F,±20%,4X5 ,50V,105℃ 4 C52 0,C52 2~C5 23,C8 09 122005000 001 STANDINDUCTOR,, DRW2 X2,4.7 UH,± 5%,19 0mA,6 2X5X 3mm 1 L1 01 12183 00201 06 E.CAP,10μ F,±20%,4X5.5,16V,85℃ 1 C41 0 142206000 004 RE C DIO DE,1N4001 ,1A,1V,50V,DO-4 1 1 D 803 12183 00201 07 E.CAP,100 μF,± 20%,6.3X5,16V,105℃ 9 C10 2,C111,C50 4,C60 6,C81 6,C81 7, 142224000 088 ZE NER DIODE ,6.8V, 1/2W 1 ZD801 C81 9,C82 2,C82 3, 142203000 003 SW DIODE,1N 4148,DO-3 5 12184 20002 24 E.CAP,0.2 2μF,± 20%, 4X5,50V,85℃ ,NON-POLARITY 12183 00002 25 E.CAP,2.2 μF,± 20%,4 X5,50V,105℃ 1 14 3 22 C10 4 J6 2,J64 ,J85, D 101~D 103,D401,D406,D 408,D 4I7, D 431,D436,D438,D4 42,D4 43,D4 26, C50 7,C51 0,C51 5~518 C524 C535 , D 434,D416,D432 C60 7~610,C121,C122 121640000 010 RCF,1Ω ,±5%, 1/8W 1 R 117 C50 3,C52 1,C82 4 121640000 222 RCF,2K2 Ω,±5 %,1/8 W 5 R 415~R 418,R429 RCF,100 Ω,±5 %,1/8W 1 R 109 12183 00002 26 E.CAP,22μ F,±20%,4X5,16V,105℃ 3 12183 00404 76 E.CAP,47μ F,±20%,5X5,16V,105℃ 3 C82 1,C82 5,C10 8 121640000 101 12183 60702 27 E.CAP,220 μF,± 20%,6.3X11 ,16V,85°C 1 C60 5 121640000 102 RCF,1KΩ ,±5% ,1/8W 1 E.CAP,330 0μF,± 20%,13X26 ,16V, 105° R 105 12184 20303 38 1 L80 1 121640000 103 RCF,10K Ω,±5 %,1/8 W 8 R 512,R513,R527,R4 20,R111,R8 01, 12201 50000 16 CHO KE COIL,47 0UH,1A,±30%,28 mm(D)X29m m(H)X 1 121640000 224 RCF,220 KΩ,± 5%,1/ 8W 1 R 529 R 823,R436, 12.5 mm(L )(CM2 03) 14220 60000 06 REC 14225 70000 01 DIO DE,1N540 1,3A, 1V, 100V, DO- 27 1 D80 1 121640000 472 RCF,4K7 Ω,±5 %,1/8 W 2 R 435,R438 TR,2SB1243TV2Q(PN P),ATV 2 Q803,Q809 121648000 560 RCF,56Ω ,±5% ,1W 1 PTC,GBX050 R 813 12167 00001 09 1 IC8 02, 133000030 071 PC B,MB ,CMU706,94 -V0,1 52.6× 173.6 × 1.6m m 1 14240 00000 40 IC,78L05,TO-92 ,UTC/ST/KE C 1 IC8 03 121604000 000 RE S,0Ω ,±5%,1/16W,0603 3 IC,KIA7027,TO-92,KEC R 818,R 411, R412 14240 00001 84 1 IC4 02 121604000 100 RE S,10Ω ,±5% ,1/16 W,060 3 3 R 401,R408,R409, 14240 00103 79 IC,TDA73 84,FLEXIWATT25, ST 1 IC8 01 121604000 101 RE S,100 Ω,±5 %,1/1 6W,06 03 12 14282 00000 34 CRYSTAL ,9.0MHZ,±3 0PPm ,-20℃ +70℃ ,HC-49/US DIP 18PF 1 XT4 01 121604000 102 RE S,1KΩ ,±5% ,1/16 W,060 3 4 12480 00000 25 FUSE,ZH270,15A,SLOW FUSE TY PE 1 121604000 103 RE S,10K Ω,±5 %,1/1 6W,06 03 14481 50000 04 TUNER,CET-702CFYA,FM/O IRT 1 TUN101 12383 00100 86 CM700,20PIN,P WR/SPK EST-KNT-20-0 4 1 SK801 12380 50000 17 14P IN,2.0 mm,WAFER 90° 1 CO N401 121604000 104 RE S,100 KΩ,± 5%,1/ 16W,0 603 9 7PIN,2.0mm,WAFER DIP 180° R 118,R1 32,R4 28,R4 30,R5 22~R5 25,R121 12380 50001 01 1 CO N403 121604010 105 RE S,1M Ω,±1% ,1/16 W,060 3 3 R 421,R422,R708 12380 00000 24 33P IN,1.2 5mm,FPC SOCKET DIP TYPE(90°) 1 CO N402 121604000 153 RE S,15K Ω,±5 %,1/1 6W,06 03 1 R 505 121604000 151 RE S,150 Ω,±5 %,1/1 6W,06 03 1 R 103 121604000 152 RE S,1K5 Ω,±5 %,1/1 6W,06 03 1 R 104 TOP CONNECT TYPE 14 R 402~R 407,R444,R614~R 617,R 410 R 106,R119,R4 49,R8 15 R 102,,R 112,R 419,R 425,R 532,R5 34, R 607,R608,R804~R805,R 807~R 809, R 821 12382 50001 07 BAR CON.,2PIN,AWG2 8#,150mm, White/Black 1 14100 00003 19 CM226,BRACKET IC 7386,S ECC,T0.8 1 121604000 222 RE S,2K2 Ω,±5 %,1/1 6W,06 03 5 R 126,R128~R130,R413 1 121604000 223 RE S,22K Ω,±5 %,1/1 6W,06 03 1 R 437 1 121604000 224 RE S,220 KΩ,± 5%,1/ 16W,0 603 3 R 426,R528,R530 J45 121604000 331 RE S,330 Ω,±5 %,1/1 6W,06 03 1 R 526 J17 ,J25,J 26,J3 6,J43, J47,J5 1,J71 , 121604000 332 RE S,3K3 Ω,±5 %,1/1 6W,06 03 4 R 113~114,R508~R5 09 J72 ,J84,J 90,J9 1,J99, J101~ J103, 121604000 471 RE S,470 Ω,±5 %,1/1 6W,06 03 2 R 110,R1 20 J10 5,J10 8, 121604000 472 RE S,4K7 Ω,±5 %,1/1 6W,06 03 4 R 131,R450,R510~R511 121604000 473 RE S,47K Ω,±5 %,1/1 6W,06 03 15 83822 CMU7 06MB 093 4X4 V ESP FM O IRT MB SMT Assm 83821 CMU7 06MB 103 CMU706 4X4V ESP FM /OIRT MB A/I Assm 11385 00000 36 ∮0. 5mm,5.0mm 11385 00000 39 ∮0. 5mm,6mm 1 20 FM OSC 11385 00000 41 ∮0. 5mm,7mm 22 J4, J5,J7, J14,J1 9,J28 ,J31,J 32,J34, 11385 00000 43 ∮0. 5mm,8mm 8 J8, J12, J 16, J3 7,J78, J21, J 10,J11 2 11385 00000 45 ∮0. 5mm,9mm 6 J2, J46,J5 8,J80 ,J81,J 104 121604000 474 RE S,470 KΩ,± 5%,1/ 16W,0 603 1 R 540 11385 00000 44 ∮0. 5mm,9.5mm 1 J44 , 121604000 512 RE S,5K1 Ω,±5 %,1/1 6W,06 03 1 ∮0. 5mm,10mm R 533 11385 00000 02 9 J1, J23,J2 7,J48 ,J75,J 88, J95,J96, J83 121604000 562 RE S,5K6 Ω,±5 %,1/1 6W,06 03 3 ∮0. 5mm,11mm R 506~R 507,R806 11385 00000 04 7 J15 , J22, J24, J 29, J3 9,J87, J70 121604000 681 RE S,680 Ω,±5 %,1/1 6W,06 03 1 R 423 11385 00000 06 ∮0. 5mm,12mm 4 J30 ,J59,J 77,J9 4, 121604000 752 RE S,7K5 Ω,±5 %,1/1 6W,06 03 5 ∮0. 5mm,13mm R 601,R602,R610,R6 13,R8 03 11385 00000 08 1 J18 121604000 823 RE S,82K Ω,±5 %,1/1 6W,06 03 1 R 531 11385 00000 10 ∮0. 5mm,14mm 1 J65 , 121606000 100 RE S,10Ω ,±5% ,1/10 W,080 5 1 ∮0. 5mm,14.5mm R 609 11385 00000 09 1 J73 , 121606000 102 RE S,1KΩ ,±5% ,1/10 W,080 5 2 R 810,,R 820 11385 00000 12 ∮0. 5mm,15mm 1 J42 , 121606000 022 RE S,2R2 Ω,±5 %,1/1 0W,08 05 1 ∮0. 5mm,16mm R 535 11385 00000 14 7 J3, J11, J 13, J20,J61, J76,J8 2, 121803000 101 CA P,100 pF,±5 %,50V,NPO ,0603 1 C 114 11385 00000 16 ∮0. 5mm,17mm 4 J68 ,J86,J 54,J113 121803000 102 CA P,1nF,±10% ,16V, X7R,0 603 5 C 106,C126,C128,C5 05~C 506 11385 00000 22 ∮0. 5mm,20mm 4 J40 ,J55,J 60,63 , 121803000 103 CA P,0.0 1μF,± 10%,50V,X7 R,060 3 8 ∮0. 5mm,22mm C 103,C107,C125,C1 27,C1 29,C4 08~ 11385 00000 25 3 J67 ,J97,J 98, R 127,R442,R605~R606,R 611~R 612, R 814,R618~R619,R603~R 604 C 409, C412 7-6 7-6 ELECTRICAL PARTS LIST - MAIN BOARD Q TY Loc ation Part N O. Des criptio n 12180 30001 04 CAP,0.1μ F,+80% -20%,16V,Y5V,0603 12180 00201 05 CAP,1μF,±10% ,16V,X7R,0603 1 C81 8 12180 30001 53 CAP,0.015μF,± 10%,50V,X7 R,060 3 2 C11 7,C11 8 12180 30002 23 CAP,0.022μF,± 10%,50V,X7 R,060 3 4 C10 1,C10 5,C11 2,C11 5 12180 30003 30 CAP,33pF,±5%, 50V,NPO,0603 2 C40 1,C40 2 12180 30002 22 CAP,2200pF,±1 0%,50 V,X7R,0603 2 C11 9,C12 0 12180 30003 34 CAP,0.33μ F,+80 %,-20%,50V,Z5U, 0603 2 C50 8,C50 9 14224 50000 15 TR,DTC343TK,SOT-23 4 Q501~50 4 14225 10000 01 TR,2N390 4(NPN),SOT -23 7 Q102~Q1 04,Q1 07,Q4 08,Q5 05,Q8 13 14224 50000 48 TR,MMBT 3906LT1,SOT-23,PNP 1 Q108 14224 50000 20 TR,KRC106S(NPN),SOT-23 9 Q101,Q105,Q109,Q402,Q507,Q804, 14224 50000 17 TR,KRA102S(PNP),SO T-23 4 Q403,Q506,Q811~Q8 12 14240 00001 40 IC,CSC23 13F,SO-28,YOUDA 1 IC5 01 14240 00005 06 IC,UTC4558,SO P-8,UTC 2 IC6 01,IC6 02 14240 00004 98 IC,NEO-791NRF,100-Q FP-1420C,DONGSUNG ,(SB8 310) 1 IC4 01 14229 00000 03 ESD DIODE,PG 05GBUSV,24A,200 W,5G 3 ZD401~4 03 12180 30004 71 CAP,470pF,±10 %,50V,X7R,0603 4 C80 5~C8 08 12180 60002 25 CAP,2.2μ F,+80% ,-20%,16V, X7R,0805 4 C80 1~C8 04 12164 00001 02 RCF,1KΩ, ±5%,1/8W 4 R62 0~R6 23 18 C10 9~C110,C116,C12 3,C40 3,C40 5~ C40 7,C411,C511~C51 4, Q807,Q810,Q802 8-1 EXPLODED VIEW - MAIN UNIT 8-1 8-2 8-2 MECHANICAL PARTS LIST(BLACK PANEL, WITHOUT RDS) Assem bly Part NO D esc rip tion QT Y Item Assembly Part N O Desc ription 1 83823CMU705KB020 C MU70 5-58A Black MCE- 525U A ssm 1 51 121 218020063 CMU 705,PANEL- FRON T,ABS (W/OD ISCP ROLO GY) 1 2 141298000021 C M700 ,RIM,ABS(B LACK) 1 52 141 237000306 CMU 705,KN OB-B AND- NUM-A MS,P C 1 3 121040000089 S CREW,BTS ,BLACK Zinc ,M2.6 X10.0 2 53 141 237020307 CMU 705,KN OB-O PEN, PC 1 4 121490000034 C MU70 5,DUSTPRO OF-S TUD 1 54 121 440000037 CM70 0,E-WASHE R,4X0 .5 2 5 141248010005 C MU70 5,CAB INET, ABS 6 121040000083 S CREW,BTS ,White Ni,M2 .6X5 I tem QT Y 1 55 121 035000332 CMV100,SP RING RELE ASE NEW,0 .3mm, 1 19 56 838 22CMU705K B000 CMU 705 KB SMT Assm 1 57 141 290010264 CMU 705,LI GHT G UIDE ,PC 1 7 121025010155 C M700 ,RIVE T PAN EL 2 8 141000010034 C M700 ,BRAC KET-PANEL -RIGH T,SEC C,T1.0 1 58 141 237000308 CMU 705,KN OB-P WR,P C 1 9 141200000086 C MU70 6,PUS H,PO M 1 59 141 237000309 CMU 705,KN OB-S RC-M UTE-DSIP-NO RD S,PC 1 10 121035000139 C MU70 6,HANDSPI KE-SP RING PRT,? . 55 1 60 141 295000015 CMU 705,DECOR ATED- RING,ABS 1 11 121040000185 S CREW,PTP, BLAC K Zinc ,M2X5 9 61 141 235000025 CM23 3,KNO B-EN CODER,AB S 1 12 83823CMU706FC000 C MU70 6 FC M I Ass m 1 62 121 035000136 CM70 0,L/& R ROTATING SPRING, Ö 0.40 2 13 141290000263 C MU70 6,LOC KER, POM 1 63 121 025000153 CM70 0,RIG HT SL IDE B LOCK SHAF T 1 14 121035000140 C MU70 6,LOC K SPR ING P RT,? .6 0 1 64 141 200000084 CM70 0,RIG HT-SL IDE,P OM 1 15 121025000157 C MU70 6,SHA FT-LO CK P RT 1 65 121 040000120 SCRE W,FT P,BLA CK Zin c,M2. 0X8 6 16 83823CMU706LB0 00 C MU70 6 LB M I Assm 1 66 141 218010064 CMU 705,PANELB ACK,A BS 1 17 121450000071 C M700 S,DUS TPRO OF, 1 67 141 200000085 CM70 0,LEF T-SLI DE,PO M 1 18 121040000186 S CREW,PTS ,Color Znic,M 2.0X4 5 68 121 025000152 CM70 0,LEF T SLID E BLO CK SHAFT 1 19 121200000087 C MU70 6,DAM PER( 45g), NYLON 1 69 121 290000237 CM70 0,BAC K LIG HTING SHE ET 1 20 121440000031 C D206 ,FELT-16-02 5,种3.5 X 1.5 X0.25 ,Grap hite fib re 2 70 121 490000120 CM20 3,ZEB RA ST RIP 1 21 141200010082 C M700 ,GEAR ,POM 1 71 121 460000027 CAD4 15,LIGHT S HIELD ING SHEET,Tinse l Shee t,T0.15 1 22 121025010154 C M700 ,RIVE T GEA R 1 72 141 290000043 CA-C 310,BACKLIGHTG UIDE ,PmmA 1 23 141000000063 C M700 ,BRAC KET-D AMP ER,SE CC,T1 .0 1 73 143 405000060 LED, WHITE , Ö3,2 04-15 AUWW,20MA ,3.5V 2 24 141237010225 C M700 ,KNOB-EJEC T,PC 1 74 121 290010238 CM70 0,FILT ER S HEET 1 25 141290000240 C M700 ,LENS GATE ,PC 1 75 143 400000048 LCD, CMU7 05,NE GATIV E COL OUR 1 26 141000000068 C M700 ,SIDE STOP R,SEC C,T1. 0 2 76 141 000000597 CMU 705,LC D CO VER,SECC, 0.6mm 1 27 141000010359 C MU70 6,BRA CKET-FRONT-U P RT,SE CC,T 1.0 1 77 121 040000086 SCRE W,BT S,Whi te Ni,M 2.6X7 1 28 121050000005 N UT,W hite Zn ic,M3 X2.5 2 78 121 040000075 SCRE W,BT S,Whi te Ni,M 2.6X1 0 1 29 121040000047 S CREW,BM,W hite N i,M3X8 2 79 838 23CMU708S D001 CMU 708 US D+SD MI As sm 1 30 121040000154 S CREW,PA ,W hite Ni,M2. 6X8 2 80 141 490000118 CM70 0,FIXTURE FOR O UT LI NE,SE CC 0. 8MM 1 31 141000000358 C MU50 1,BRA CKET DECK FRO NT OF CLC0 1,SEC C,T1. 0 1 32 83823CMU706SB002 C MU70 6 SB M I Ass m 1 33 144840030017 D ECK,CL-C0 1FY7( SHINWA) 1 34 121040000101 S CREW,CM,C olor Z nic,M 2.6x19 ,(SHI NWA CL-C01 ) 2 35 141000020341 C M701 ,TOPC OVER ,SECC,T0.6 2 36 121000010334 C M700 ,DECK REAR BRA CKET, SECC,T1.0 1 37 121040000069 S CREW,BTS ,White Znic,M 2.6X 3 2 38 121050000003 C MV10 0,POL E 1 39 121410000026 C MV10 0,RUB BER 1 40 121040000077 S CREW,BTS ,White Ni,M2 .6X14 2 41 141000000067 C AD31 0,SHO RT SH EET,S ECC, T0.6 1 42 124845000001 A NTEN NA,W /GROU ND 2 30mm 1 43 121040000059 S CREW,BTB ,White Ni,M2 .6X21 2 44 141010020047 C ME0C M700 ,HEAT SINK 1 45 121000030076 C AD51 0,BRA CKET-REAR-U,SE CC,T 1.0 1 46 141000000319 C M226 ,BRAC KET I C 738 6,SEC C,T0.8 1 47 83823CMU706MB113 C MU70 6 4X4 V ESP FM/O IRT MB MI A ssm 1 48 121040000222 S CREW,pFM ,BLACK Zinc ,M2.6 X5 2 49 121290000662 C M725 ,ISOLATOR SHEE T,PC S HEET (T=0.1 85mm ),CM7 25 1 50 141228010411 C MU70 5,LEN S,Pm mA 1 8-3 8-3 MECHANICAL PARTS LIST(SILVER PANEL, WITHOUT RDS) Assem bly Part NO D esc rip tion QT Y Item Assembly Part N O Desc ription 1 83823CMU705KB030 C MU70 5-58B SILVE MCE -525U Assm 1 51 121 217020041 CMU 705,PANEL- FRON T,ABS (W/OD ISCP ROLO GY) 1 2 141297000025 C M700 ,RIM,ABS(S ILVER ) 1 52 141 237000306 CMU 705,KN OB-B AND- NUM-A MS,P C 1 3 121040000089 S CREW,BTS ,BLACK Zinc ,M2.6 X10.0 2 53 141 237020307 CMU 705,KN OB-O PEN, PC 1 4 121490000034 C MU70 5,DUSTPRO OF-S TUD 1 54 121 440000037 CM70 0,E-WASHE R,4X0 .5 2 5 141247010002 C MU70 5,CAB INET, ABS 6 121040000083 S CREW,BTS ,White Ni,M2 .6X5 I tem QT Y 1 55 121 035000332 CMV100,SP RING RELE ASE NEW,0 .3mm, 1 19 56 838 22CMU705K B000 CMU 705 KB SMT Assm 1 57 141 290010264 CMU 705,LI GHT G UIDE ,PC 1 7 121025010155 C M700 ,RIVE T PAN EL 2 8 141000010034 C M700 ,BRAC KET-PANEL -RIGH T,SEC C,T1.0 1 58 141 237000308 CMU 705,KN OB-P WR,P C 1 9 141200000086 C MU70 6,PUS H,PO M 1 59 141 237000309 CMU 705,KN OB-S RC-M UTE-DSIP-NO RD S,PC 1 10 121035000139 C MU70 6,HANDSPI KE-SP RING PRT, Ö 0.55 1 60 141 295000015 CMU 705,DECOR ATED- RING,ABS 1 11 121040000185 S CREW,PTP, BLAC K Zinc ,M2X5 9 61 141 235000025 CM23 3,KNO B-EN CODER,AB S 1 12 83823CMU708FC000 C MU70 6 FC M I Ass m 1 62 121 035000136 CM70 0,L/& R ROTATING SPRING, Ö 0.40 2 13 141290000263 C MU70 6,LOC KER, POM 1 63 121 025000153 CM70 0,RIG HT SL IDE B LOCK SHAF T 1 14 121035000140 C MU70 6,LOC K SPR ING PRT, Ö 0 .60 1 64 141 200000084 CM70 0,RIG HT-SL IDE,P OM 1 15 121025000157 C MU70 6,SHA FT-LO CK P RT 1 65 121 040000120 SCRE W,FT P,BLA CK Zin c,M2. 0X8 6 16 83823CMU706LB0 00 C MU70 6 LB M I Assm 1 66 141 218010064 CMU 705,PANELB ACK,A BS 1 17 121450000071 C M700 S,DUS TPRO OF, 1 67 141 200000085 CM70 0,LEF T-SLI DE,PO M 1 18 121040000186 S CREW,PTS ,Color Znic,M 2.0X4 5 68 121 025000152 CM70 0,LEF T SLID E BLO CK SHAFT 1 19 121200000087 C MU70 6,DAM PER( 45g), NYLON 1 69 121 290000237 CM70 0,BAC K LIG HTING SHE ET 1 20 121440000031 C D206 ,FELT-16-02 5,种3.5 X 1.5 X0.25 ,Grap hite fib re 2 70 121 490000120 CM20 3,ZEB RA ST RIP 1 21 141200010082 C M700 ,GEAR ,POM 1 71 121 460000027 CAD4 15,LIGHT S HIELD ING SHEET,Tinse l Shee t,T0.15 1 22 121025010154 C M700 ,RIVE T GEA R 1 72 141 290000043 CA-C 310,BACKLIGHTG UIDE ,PmmA 1 23 141000000063 C M700 ,BRAC KET-D AMP ER,SE CC,T1 .0 1 73 143 405000060 LED, WHITE , Ö3,2 04-15 AUWW,20MA ,3.5V 2 24 141237010225 C M700 ,KNOB-EJEC T,PC 1 74 121 290010238 CM70 0,FILT ER S HEET 1 25 141290000240 C M700 ,LENS GATE ,PC 1 75 143 400000048 LCD, CMU7 05,NE GATIV E COL OUR 1 26 141000000068 C M700 ,SIDE STOP R,SEC C,T1. 0 2 76 141 000000597 CMU 705,LC D CO VER,SECC, 0.6mm 1 27 141000010359 C MU70 6,BRA CKET-FRONT-U P RT,SE CC,T 1.0 1 77 121 040000086 SCRE W,BT S,Whi te Ni,M 2.6X7 1 28 121050000005 N UT,W hite Zn ic,M3 X2.5 2 78 121 040000075 SCRE W,BT S,Whi te Ni,M 2.6X1 0 1 29 121040000047 S CREW,BM,W hite N i,M3X8 2 79 838 23CMU708S D00 CMU 708 US D+SD MI As sm 1 30 121040000154 S CREW,PA ,W hite Ni,M2. 6X8 2 80 1141490000118 CM70 0,FIXTURE FOR O UT LI NE,SE CC 0. 8MM 1 31 141000000358 C MU70 6,BRA CKET DECK FRO NT OF CLC0 1,SEC C,T1. 0 1 32 83823CMU706SB002 C MU70 6 SB M I Ass m 1 33 144840030017 D ECK,CL-C0 1FY7( SHINWA) 1 34 121040000101 S CREW,CM,C olor Z nic,M 2.6x19 ,(SHI NWA CL-C01 ) 2 35 141000020341 C M701 ,TOPC OVER ,SECC,T0.6 2 36 121000010334 C M700 ,DECK REAR BRA CKET, SECC,T1.0 1 37 121040000069 S CREW,BTS ,White Znic,M 2.6X 3 2 38 121050000003 C MV10 0,POL E 1 39 121410000026 C MV10 0,RUB BER 1 40 121040000077 S CREW,BTS ,White Ni,M2 .6X14 2 41 141000000067 C AD31 0,SHO RT SH EET,S ECC, T0.6 1 42 124845000001 A NTEN NA,W /GROU ND 2 30mm 1 43 121040000059 S CREW,BTB ,White Ni,M2 .6X21 2 44 141010020047 C ME0C M700 ,HEAT SINK 1 45 121000030076 C AD51 0,BRA CKET-REAR-U,SE CC,T 1.0 1 46 141000000319 C M226 ,BRAC KET I C 738 6,SEC C,T0.8 1 47 83823CMU706MB113 C MU70 6 4X4 V ESP FM/O IRT MB MI A ssm 1 48 121040000222 S CREW,pFM ,BLACK Zinc ,M2.6 X5 2 49 121290000662 C M725 ,ISOLATOR SHEE T,PC S HEET (T=0.1 85mm ),CM7 25 1 50 141228010411 C MU70 5,LEN S,Pm mA. 1 8-4 8-4 MECHANICAL PARTS LIST(BLACK PANEL, WITH RDS) Assem bly Part NO D esc rip tion QT Y Item Assembly Part N O Desc ription 1 83823CMU705KB000 C MU70 5-58C Black PANEL SILV E KNO B Ass m 1 51 121 218020124 CMU 705,PANEL- FRON TBLACK,AB S 1 2 141298000021 C M700 ,RIM,ABS(B LACK) 1 52 141 237000306 CMU 705,KN OB-B AND- NUM-A MS,P C 1 3 121040000089 S CREW,BTS ,BLACK Zinc ,M2.6 X10.0 2 53 141 237020307 CMU 705,KN OB-O PEN, PC 1 4 121490000034 C MU70 5,DUSTPRO OF-S TUD 1 54 121 440000037 CM70 0,E-WASHE R,4X0 .5 2 5 141248010005 C MU70 5,CAB INET, ABS 6 121040000083 S CREW,BTS ,White Ni,M2 .6X5 I tem QT Y 1 55 121 035000332 CMV100,SP RING RELE ASE NEW,0 .3mm, 1 19 56 838 22CMU705K B000 CMU 705 KB SMT Assm 1 57 141 290010264 CMU 705,LI GHT G UIDE ,PC 1 7 121025010155 C M700 ,RIVE T PAN EL 2 8 141000010034 C M700 ,BRAC KET-PANEL -RIGH T,SEC C,T1.0 1 58 141 237000308 CMU 705,KN OB-P WR,P C 1 9 141200000086 C MU70 6,PUS H,PO M 1 59 141 237000310 CMU 705,KN OB-S RC-M UTE-DSIP-RDS,P C 1 10 121035000139 C MU70 6,HANDSPI KE-SP RING PRT, Ö 0.55 1 60 141 295000015 CMU 705,DECOR ATED- RING,ABS 1 11 121040000185 S CREW,PTP, BLAC K Zinc ,M2X5 9 61 141 235000025 CM23 3,KNO B-EN CODER,AB S 1 12 83823CMU708FC000 C MU70 6 FC M I Ass m 1 62 121 035000136 CM70 0,L/& R ROTATING SPRING, Ö 0.40 2 13 141290000263 C MU70 6,LOC KER, POM 1 63 121 025000153 CM70 0,RIG HT SL IDE B LOCK SHAF T 1 14 121035000140 C MU70 6,LOC K SPR ING PRT, Ö 0 .60 1 64 141 200000084 CM70 0,RIG HT-SL IDE,P OM 1 15 121025000157 C MU70 6,SHA FT-LO CK P RT 1 65 121 040000120 SCRE W,FT P,BLA CK Zin c,M2. 0X8 6 16 83823CMU706LB0 00 C MU70 6 LB M I Assm 1 66 141 218010064 CMU 705,PANELB ACK,A BS 1 17 121450000071 C M700 S,DUS TPRO OF, 1 67 141 200000085 CM70 0,LEF T-SLI DE,PO M 1 18 121040000186 S CREW,PTS ,Color Znic,M 2.0X4 5 68 121 025000152 CM70 0,LEF T SLID E BLO CK SHAFT 1 19 121200000087 C MU70 6,DAM PER( 45g), NYLON 1 69 121 290000237 CM70 0,BAC K LIG HTING SHE ET 1 20 121440000031 C D206 ,FELT-16-02 5,种3.5 X 1.5 X0.25 ,Grap hite fib re 2 70 121 490000120 CM20 3,ZEB RA ST RIP 1 21 141200010082 C M700 ,GEAR ,POM 1 71 121 460000027 CAD4 15,LIGHT S HIELD ING SHEET,Tinse l Shee t,T0.15 1 22 121025010154 C M700 ,RIVE T GEA R 1 72 141 290000043 CA-C 310,BACKLIGHTG UIDE ,PmmA 1 23 141000000063 C M700 ,BRAC KET-D AMP ER,SE CC,T1 .0 1 73 143 405000060 LED, WHITE , Ö3,2 04-15 AUWW,20MA ,3.5V 2 24 141237010225 C M700 ,KNOB-EJEC T,PC 1 74 121 290010238 CM70 0,FILT ER S HEET 1 25 141290000240 C M700 ,LENS GATE ,PC 1 75 143 400000048 LCD, CMU7 05,NE GATIV E COL OUR 1 26 141000000068 C M700 ,SIDE STOP R,SEC C,T1. 0 2 76 141 000000597 CMU 705,LC D CO VER,SECC, 0.6mm 1 27 141000010359 C MU70 6,BRA CKET-FRONT-U P RT,SE CC,T 1.0 1 77 121 040000086 SCRE W,BT S,Whi te Ni,M 2.6X7 1 28 121050000005 N UT,W hite Zn ic,M3 X2.5 2 78 121 040000075 SCRE W,BT S,Whi te Ni,M 2.6X1 0 1 29 121040000047 S CREW,BM,W hite N i,M3X8 2 79 838 23CMU708S D001 CMU 708 US D+SD MI As sm 1 30 121040000154 S CREW,PA ,W hite Ni,M2. 6X8 2 80 141 490000118 CM70 0,FIXTURE FOR O UT LI NE,SE CC 0. 8MM 1 31 141000000358 C MU70 6,BRA CKET DECK FRO NT OF CLC0 1,SEC C,T1. 0 1 32 83823CMU706SB002 C MU70 6 SB M I Ass m 1 33 144840030017 D ECK,CL-C0 1FY7( SHINWA) 1 34 121040000101 S CREW,CM,C olor Z nic,M 2.6x19 ,(SHI NWA CL-C01 ) 2 35 141000020341 C M701 ,TOPC OVER ,SECC,T0.6 2 36 121000010334 C M700 ,DECK REAR BRA CKET, SECC,T1.0 1 37 121040000069 S CREW,BTS ,White Znic,M 2.6X 3 2 38 121050000003 C MV10 0,POL E 1 39 121410000026 C MV10 0,RUB BER 1 40 121040000077 S CREW,BTS ,White Ni,M2 .6X14 2 41 141000000067 C AD31 0,SHO RT SH EET,S ECC, T0.6 1 42 124845000001 A NTEN NA,W /GROU ND 2 30mm 1 43 121040000059 S CREW,BTB ,White Ni,M2 .6X21 2 44 141010020047 C ME0C M700 ,HEAT SINK 1 45 121000030076 C AD51 0,BRA CKET-REAR-U,SE CC,T 1.0 1 46 141000000319 C M226 ,BRAC KET I C 738 6,SEC C,T0.8 1 47 83823CMU706MB103 C MU70 6 4X4 V RDS ESP F M/OIRT 4VS UB A UXI MB MI Assm 1 48 121040000222 S CREW,pFM ,BLACK Zinc ,M2.6 X5 2 49 121290000662 C M725 ,ISOLATOR SHEE T,PC S HEET (T=0.1 85mm ),CM7 25 1 50 141228010412 C MU70 5,LEN S,Pm mA(W RDSP ROLO GY) 1 8-5 8-5 MECHANICAL PARTS LIST(SILVER PANEL, WITH RDS) Assem bly Part NO D esc rip tion QT Y Item Assembly Part N O Desc ription 1 83823CMU705KB010 C MU70 5-58D SILVE KB M I Assm 1 51 141 217020072 CMU 705,PANEL- FRON TBLACK,AB S 1 2 141297000025 C M700 ,RIM,ABS(S ILVER ) 1 52 141 237000306 CMU 705,KN OB-B AND- NUM-A MS,P C 1 3 121040000089 S CREW,BTS ,BLACK Zinc ,M2.6 X10.0 2 53 141 237020307 CMU 705,KN OB-O PEN, PC 1 4 121490000034 C MU70 5,DUSTPRO OF-S TUD 1 54 121 440000037 CM70 0,E-WASHE R,4X0 .5 2 5 141247010002 C MU70 5,CAB INET, ABS 6 121040000083 S CREW,BTS ,White Ni,M2 .6X5 I tem QT Y 1 55 121 035000332 CMV100,SP RING RELE ASE NEW,0 .3mm, 1 19 56 838 22CMU705K B000 CMU 705 KB SMT Assm 1 57 141 290010264 CMU 705,LI GHT G UIDE ,PC 1 7 121025010155 C M700 ,RIVE T PAN EL 2 8 141000010034 C M700 ,BRAC KET-PANEL -RIGH T,SEC C,T1.0 1 58 141 237000308 CMU 705,KN OB-P WR,P C 1 9 141200000086 C MU70 6,PUS H,PO M 1 59 141 237000310 CMU 705,KN OB-S RC-M UTE-DSIP-RDS,P C 1 10 121035000139 C MU70 6,HANDSPI KE-SP RING PRT, Ö 0.55 1 60 141 295000015 CMU 705,DECOR ATED- RING,ABS 1 11 121040000185 S CREW,PTP, BLAC K Zinc ,M2X5 9 61 141 235000025 CM23 3,KNO B-EN CODER,AB S 1 12 83823CMU708FC000 C MU70 6 FC M I Ass m 1 62 121 035000136 CM70 0,L/& R ROTATING SPRING, Ö 0.40 2 13 141290000263 C MU70 6,LOC KER, POM 1 63 121 025000153 CM70 0,RIG HT SL IDE B LOCK SHAF T 1 14 121035000140 C MU70 6,LOC K SPR ING PRT, Ö 0 .60 1 64 141 200000084 CM70 0,RIG HT-SL IDE,P OM 1 15 121025000157 C MU70 6,SHA FT-LO CK P RT 1 65 121 040000120 SCRE W,FT P,BLA CK Zin c,M2. 0X8 6 16 83823CMU706LB0 00 C MU70 6 LB M I Assm 1 66 141 218010064 CMU 705,PANELB ACK,A BS 1 17 121450000071 C M700 S,DUS TPRO OF, 1 67 141 200000085 CM70 0,LEF T-SLI DE,PO M 1 18 121040000186 S CREW,PTS ,Color Znic,M 2.0X4 5 68 121 025000152 CM70 0,LEF T SLID E BLO CK SHAFT 1 19 121200000087 C MU70 6,DAM PER( 45g), NYLON 1 69 121 290000237 CM70 0,BAC K LIG HTING SHE ET 1 20 121440000031 C D206 ,FELT-16-02 5,种3.5 X 1.5 X0.25 ,Grap hite fib re 2 70 121 490000120 CM20 3,ZEB RA ST RIP 1 21 141200010082 C M700 ,GEAR ,POM 1 71 121 460000027 CAD4 15,LIGHT S HIELD ING SHEET,Tinse l Shee t,T0.15 1 22 121025010154 C M700 ,RIVE T GEA R 1 72 141 290000043 CA-C 310,BACKLIGHTG UIDE ,PmmA 1 23 141000000063 C M700 ,BRAC KET-D AMP ER,SE CC,T1 .0 1 73 143 405000060 LED, WHITE , Ö3,2 04-15 AUWW,20MA ,3.5V 2 24 141237010225 C M700 ,KNOB-EJEC T,PC 1 74 121 290010238 CM70 0,FILT ER S HEET 1 25 141290000240 C M700 ,LENS GATE ,PC 1 75 143 400000048 LCD, CMU7 05,NE GATIV E COL OUR 1 26 141000000068 C M700 ,SIDE STOP R,SEC C,T1. 0 2 76 141 000000597 CMU 705,LC D CO VER,SECC, 0.6mm 1 27 141000010359 C MU70 6,BRA CKET-FRONT-U P RT,SE CC,T 1.0 1 77 121 040000086 SCRE W,BT S,Whi te Ni,M 2.6X7 1 28 121050000005 N UT,W hite Zn ic,M3 X2.5 2 78 121 040000075 SCRE W,BT S,Whi te Ni,M 2.6X1 0 1 29 121040000047 S CREW,BM,W hite N i,M3X8 2 79 838 23CMU708S D001 CMU 708 US D+SD MI As sm 1 30 121040000154 S CREW,PA ,W hite Ni,M2. 6X8 2 80 141 490000118 CM70 0,FIXTURE FOR O UT LI NE,SE CC 0. 8MM 1 31 141000000358 C MU70 6,BRA CKET DECK FRO NT OF CLC0 1,SEC C,T1. 0 1 32 83823CMU706SB002 C MU70 6 SB M I Ass m 1 33 144840030017 D ECK,CL-C0 1FY7( SHINWA) 1 34 121040000101 S CREW,CM,C olor Z nic,M 2.6x19 ,(SHI NWA CL-C01 ) 2 35 141000020341 C M701 ,TOPC OVER ,SECC,T0.6 2 36 121000010334 C M700 ,DECK REAR BRA CKET, SECC,T1.0 1 37 121040000069 S CREW,BTS ,White Znic,M 2.6X 3 2 38 121050000003 C MV10 0,POL E 1 39 121410000026 C MV10 0,RUB BER 1 40 121040000077 S CREW,BTS ,White Ni,M2 .6X14 2 41 141000000067 C AD31 0,SHO RT SH EET,S ECC, T0.6 1 42 124845000001 A NTEN NA,W /GROU ND 2 30mm 1 43 121040000059 S CREW,BTB ,White Ni,M2 .6X21 2 44 141010020047 C ME0C M700 ,HEAT SINK 1 45 121000030076 C AD51 0,BRA CKET-REAR-U,SE CC,T 1.0 1 46 141000000319 C M226 ,BRAC KET I C 738 6,SEC C,T0.8 1 47 83823CMU706MB103 C MU70 6 4X4 V RDS ESP F M/OIRT 4VS UB A UXI MB MI Assm 1 48 121040000222 S CREW,pFM ,BLACK Zinc ,M2.6 X5 2 49 121290000662 C M725 ,ISOLATOR SHEE T,PC S HEET (T=0.1 85mm ),CM7 25 1 50 141228010412 C MU70 5,LEN S,Pm mA(W RDSP ROLO GY) 1