Download Service Manual
Transcript
Service Manual ViewSonic VA712b-2 Model No VS10901 17” Color TFT LCD Display Manufacture Date: Mar-30-06 -1– ViewSonic Corporation Copyright ® Copyright © 2005 by ViewSonic Corporation. All rights reserved. No part of this publication may be reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language or manual or otherwise, without the prior written permission of ViewSonic Corporation. Disclaimer ® ViewSonic makes no representation or warranties, either expressed or implied, with respect to the contents hereof and specifically disclaims any warranty of merchantability of fitness for any particular purpose. Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes. Trademarks Optiquest is a registered trademark of ViewSonic Corporation. ® ViewSonic is a registered trademark of ViewSonic Corporation. All other trademark used within this document are the property of their respective owners. Revision History Revision Date Description of changes Approval A00 Sep-9-05 Initial Release YG.WANG A01 Mar-30-06 Update the Handing and Placing Methods and the Circuit Description and the Adjustment Procedure YG.WANG -2– ViewSonic Corporation TABLE OF CONTENTS 1. Precautions And Safety Notices 4 2. Specification 7 3. Front Panel Control And Indicators 11 4. Circuit Description 17 5. Adjusting Procedure 27 6. Troubleshooting Flow Chart 47 7. Recommended Spare Parts List 48 8. Exploded Diagram And Spare Parts List 66 9. Disassemble Process 70 10. Block Diagram 75 11. Schematic Diagram 76 12. PCB Layout Diagram 83 -3– ViewSonic Corporation 1. Precautions And Safety Notices 1.1 SAFETY PRECAUTIONS This monitor is manufactured and tested on a ground principle that a user’s safety comes first. However, improper use or installation may cause damage to the monitor as well as the user. Carefully go over the following WARNINGS before installing and keep this guide handy. WARNINGS .This monitor should be operated only at the correct power sources indicated on the label on the rear end of the monitor. If you’re unsure of the power supply in your residence, consult you local dealer or power company. .Use only the special power adapter that comes with this monitor for power input. .Do not try to repair the monitor your self as it contains no user-serviceable parts. This monitor should only be repaired by a qualified technician. .Do not remove the monitor cabinet. There is high-voltage parts inside that may cause electric shock to human bodies, even when the power cord is unplugged. .Stop using the monitor if the cabinet is damaged. Have it checked by a service technician. .Put your monitor only in a clean, dry environment. If it gets wet, unplug the power cable immediately and consult your service technician. .Always unplug the monitor before cleaning it .Clean the cabinet with a clean, dry cloth. Apply non-ammonia based cleaner onto the cloth, not directly onto the glass screen. .Keep the monitor away from magnetic objects, motors, TV sets, and transformer. .Do not place heavy objects on the monitor or power cord. 1.2 PRODUCT SAFETY NOTICE Many electrical and mechanical parts in this chassis have special safety visual inspections and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltages, wattage, etc. Before replacing any of these components read the parts list in this manual carefully. The use of substitute replacement parts which do not have the same safety characteristics as specified in the parts list may create shock, fire ,or other hazards. 1.3 SERVICE NOTES 1. When replacing parts or circuit boards, clamp the lead wires around terminals before soldering. 2. When replacing a high wattage resistor(more than 1W of metal oxide film resistor) in circuit board, keep the resistor about 5mm away from circuit board. 3. Keep wires away from high voltage, high temperature components and sharp edges. 4. Keep wires in their original position so as to reduce interference. 5. Usage of this product please refer to also user’s manual. -4– ViewSonic Corporation 1.4 HANDING AND PLACING METHODS Correct Methods: Incorrect Methods: Only touch the metal frame of the LCD Surface of the LCD panel is pressed by fingers panel or the front cover of the monitor. Do and that may cause “Mura.” not touch the surface of the polarizer. Take out the monitor with cushions Taking out the monitor by grasping the LCD panel. That may cause “Mura.” -5– ViewSonic Corporation Placing the monitor on foreign objects. That Place the monitor on a clean and soft foam could scratch the surface of the panel or cause pad. “Mura.” Place the monitor on the lap, the panel The panel is placed facedown on the lap. That surface must be upwards. may cause “Mura.” -6– ViewSonic Corporation 2. Specification 2.1 PRODUCT SPECIFICATIONS LCD Panel 17.0” TFT Recommend Resolution 1280 x1024@60Hz Pixel Dimension 0.264(H) x 0.264(V)mm LCD Display Color 16.2M Colors (RGB 6-bit+FRC data) Viewing Angle Horizontal: 140 ° Vertical: 130 ° Contrast Ratio 500:1 (Typ.) Brightness 300 cd/㎡(Typ.) Response Time 8ms(Typ.) Active Display Area 337.9mm(H) x 270.3mm(V) Maximum Pixel Clock 135 MHz Horizontal Frequency 30 – 82 kHz Vertical Refresh Rate 50 – 85 Hz. Temperature Input Signal Operating: 0°C to +40°C Storage: -20°C to +60°C Analog / Digital Energy Star compliant VESA Power Management DPMS compatible ≦1 W Power Input Voltage : 90V~264ACV,50~60Hz(auto switch) Consumption: 39 Watts(Max.) -7– ViewSonic Corporation 36 Watts(Typ.) 2.2 FACTORY SUPPORTING MODES Timing Table : Item Timing Analog Digital 1 640 x 350 @ 70Hz, 31.5kHz Yes Yes 2 640 x 480 @ 60Hz, 31.5kHz Yes Yes 3 640 x 480 @ 67Hz, 35.0kHz Yes Yes 4 640 x 480 @ 72Hz, 37.9kHz Yes Yes 5 640 x 480 @ 75Hz, 37.5kHz Yes Yes 6 640 x 480 @ 85Hz, 43.27kHz Yes Yes 7 720 x 400 @ 70Hz, 31.5kHz Yes Yes 8 800 x 600 @ 56Hz, 35.1kHz Yes Yes 9 800 x 600 @ 60Hz, 37.9kHz Yes Yes 10 800 x 600 @ 72Hz, 48.1kHz Yes Yes 11 800 x 600 @ 75Hz, 46.9kHz Yes Yes 12 800 x 600 @ 85Hz, 53.7kHz Yes Yes 13 832 x 624 @ 75Hz, 49.7kHz Yes Yes 14 1024 x 768 @ 60Hz, 48.4kHz Yes Yes 15 1024 x 768 @ 70Hz, 56.5kHz Yes Yes 16 1024 x 768 @ 72Hz, 58.1kHz Yes Yes 17 1024 x 768 @ 75Hz, 60.0kHz Yes Yes 18 1024 x 768 @ 85Hz, 68.67kHz Yes Yes 19 1152 x 870 @ 75Hz, 68.6kHz Yes Yes 20 1280 x 1024 @ 60Hz, 63.4kHz Yes Yes 21 1280 x 1024 @ 75Hz, 79.97kHz Yes Yes 22 1280 x 720 @ 60Hz, 45kHz Yes Yes Primary Preset::VESA : 1280 x1024@60Hz -8– ViewSonic Corporation 2.3 INTERFACE DESCRIPTION D-SUB 15 PIN CONNECTOR 1 6 11 5 10 15 Pin Number 1 Red video input 2 Green video input 3 Blue video input 4 No Connection 5 Ground 6 Red video ground 7 Green video ground 8 Blue video ground 9 +5V 10 H/V sync ground 11 No connection 12 (SDA) 13 Horizontal sync (Composite sync) 14 Vertical sync 15 (SCL) SIGNAL LEVEL -9– ViewSonic Corporation Pin Function DVI-D 24 PIN CONNECTOR Pin No. Signal Name Description 1 RX2- TMDS negative differential input, channel 2 2 RX2+ TMDS positive differential input, channel 2 3 GND Logic Ground 4 Reserved 4 Reserved. No connection 5 Reserved 5 Reserved. No connection 6 DDC-CLK DDC2B Clock 7 DDC-DAT DDC2B Data 8 Reserved 8 Reserved. No connection 9 RX1- TMDS negative differential input, channel 1 10 11 12 RX1+ GND Reserved 12 TMDS positive differential input, channel 1 Logic Ground Reserved. No connection 13 Reserved 13 Reserved. No connection 14 VCCX Power 15 GND Logic Ground 16 SENS SENSE Pin, Pull High 17 RX0- TMDS negative differential input, channel 0 18 RX0+ TMDS positive differential input, channel 0 19 GND Logic Ground 20 Reserved 20 Reserved. No connection 21 Reserved 21 Reserved. No connection 22 GND Logic Ground 23 RXC+ TMDS positive differential input, reference clock 24 RXC- TMDS negative differential input, reference clock - 10 – ViewSonic Corporation 3. Front Panel Function Controls And Indicators - 11 – ViewSonic Corporation Do the following to adjust the display setting: 1. To display the Main Menu, press button [1]. NOTE: All OSD menus and adjustment screens disappear automatically after about 15 seconds. This is adjustable through the OSD timeout setting in the setup menu. 2. To select a control to adjust, press or ▼ to ▲ scroll up or down in the Main Menu. 3. After the desired control is selected, press button [2]. A control screen like the one shown below appears. The command line at the bottom of the control screen tells what to do next from this screen. You can toggle between control screens, adjust the selected option, or exit the screen. 4. To adjust the setting, press the up ▼ or ▲ down T buttons. 5. To save the adjustments and exit the menu, press button [1] twice. The following tips may help you optimize your display: • Adjust the computer's graphics card so that it outputs a 1280 x 1024 @ 60Hz video signal to the LCD display. (Look for instructions on “changing the refresh rate” in the graphics card's user guide.) • If necessary, make small adjustments using H. POSITION and V. POSITION until the screen image is completely visible. (The black border around the edge of the screen should barely touch the illuminated “active area” of the LCD display.) - 12 – ViewSonic Corporation Main Menu Controls Adjust the menu items shown below by using the up Control and down buttons. Explanation Auto Image Adjust sizes and centers the screen image automatically. Contrast adjusts the difference between the image background (black level) and the foreground (white level). Brightness adjusts background black level of the screen image. Input Select allows the user to toggle between an analog and a digital signal. Audio Adjust Volume increases the volume, decreases the volume, and mutes the audio. Mute temporarily silences audio output. Color Adjust provides several color adjustment modes, including preset color temperatures and a User Color mode which allows independent adjustment of red (R), green (G), and blue (B). The factory setting for this product is 6500K (6500 Kelvin). 9300K-Adds blue to the screen image for cooler white (used in most office settings with fluorescent lighting). 6500K-Adds red to the screen image for warmer white and richer red. 5400K-Adds green to the screen image for a darker color. 5000K-Adds blue and green to the screen image for a darker color. User Color Individual adjustments for red (R), green (G), and blue (B). 1. To select color (R, G or B) press button [2]. 2. To adjust selected color, press ▼ and ▲. Important: If you select RECALL from the Main Menu when the product is set to a Preset Timing Mode, colors return to the 6500K factory preset. - 13 – ViewSonic Corporation Information displays the timing mode (video signal input) coming from the graphics card in the computer, the LCD model number, the serial number, and ® the ViewSonic website URL. See your graphics card’s user guide for instructions on changing the resolution and refresh rate (vertical frequency). NOTE: VESA 1280 x 1024 @ 60Hz (recommended) means that the resolution is 1280 x 1024 and the refresh rate is 60 Hertz. Manual Image Adjust Sub-menu H. Size (Horizontal Size) adjusts the width of the screen image. H./V. Position (Horizontal/Vertical Position) moves the screen image left or right and up or down. Fine Tune sharpens the focus by aligning text and/or graphics with pixel boundaries. NOTE: Try Auto Image Adjust first. Sharpness adjusts the clarity and focus of the screen image. - 14 – ViewSonic Corporation Setup Menu displays the menu shown below: Language Select allows the user to choose the language used in the menus and control screens. Resolution Notice allows the user to enable or disable this notice. If you enable the Resolution Notice shown above and your computer is set at a resolution other than 1280 x 1024, the following screen appears. OSD Position allows the user to move the OSD menus and control screens. OSD Timeout sets the length of time the OSD screen is displayed. For example, with a “30 second” setting, if a control is not pushed within 30 seconds, the display screen disappears. OSD Background allows the user to turn the OSD background On or Off. Memory Recall returns the adjustments back to factory settings if the display is operating in a factory Preset Timing Mode listed in the Specifications of this manual. - 15 – ViewSonic Corporation SHORT CUTS FUNCTION FROM THE BUTTONS [1] Main Menu [2] Auto Image Adjust [▼] or [▲] To immediately activate Contrast menu. It should be change to Brightness OSD by push button [2] [▼] + [▲] Recall Contrast or Brightness while in the Contrast or Brightness adjustment, or recall both of Contrast and Brightness when the OSD is not open. [1] + [2] Toggle 720x400 and 640x400 mode when input 720x400 or 640x400 mode [1] + [▼] + [▲] White Balance (Not shown on user’s guide) [1] + [▼] • Power Lock: Press and hold “[2], & ▼” for 10 seconds. If the power button is pressed the message Power Button Locked will display for 5 seconds. With or without this setting, after a power failure, your LCD display’s power will automatically turn ON when power is restored. • Power Unlock: Press and hold “[2], & ▼” again for 10 seconds. [1] + [▲] • OSD Lock: Press and hold "[1], & (▲)" for 10 seconds. If any buttons are pressed the message OSD Locked will display for 5 seconds. • OSD Unlock: Press and hold “[1], & ▲” again for 10 seconds. [;U] Volume mute on/off Remark : All the short cuts function are only available while OSD off - 16 – ViewSonic Corporation 4. Circuit Description 4.1 LCD MONITOR DESCRIPTION The LCD MONITOR will contain a Main Board, an Power Board, Key Board which house the flat panel control logic, brightness control logic and DDC. The Power Board will provide AC to DC Inverter voltage to drive the backlight of panel and the Main Board chips each voltage. Monitor Block Diagram CCFL Drive. Flat Panel and CCFL backlight Main Board Power Board (Include: adapter, inverter) RS232 Connector For white balance adjustment in factory mode Video signal, DDC Key Board AC-IN 100V-240V HOST Computer - 17 – ViewSonic Corporation 4.2 POWER BLOCK FUNCTION DESCRIPTION Inverter Block Function - 18 – ViewSonic Corporation Power Block Function - 19 – ViewSonic Corporation 4.4 INTRODUCTION OF IC RTD2523B-LF(U401): integrate ADC, OSD, TMPS, RSDS TX, LVDS TX, convert analog RGB into digital and room and shrink scaling output to LCD panel. PIN Function: Pin 127 128 Symbol XO XI 50 51 121 120 123 110/48 124 109 58 5 DDCSCL1(ADC) DDCSDA1(ADC) DDCSCL2(DVI) DDCSDA2(DVI) RESET_OUT COUT 33VRST_REF 33VPNLOUT BJT_B TMDS_TST 7/13 6 49/112 4/48/111 3/5/122 4 125 2 3 4 56/118 57/119 59/83/108 47/116 21/38 40 19 TMDS_VDD REXT PWM2 PWM1 PWM0 BYPASS DPLL_VDD APLL_VDD PLL_TEST1 PLL_TEST2 SCSB SCLK Pad 3.3V Power Digital 1.8V Power ADC_VDD VCLK AVSO 20 AHSO Description Crystal OSC output Reference clock input from external crystal or from single-ended CMOS/TTL OSC(3.3V tolerance) Open drain(Internal 75K pull high) Open drain(Internal 75K pull high) Open drain(Internal 75K pull high) Open drain(Internal 75K pull high) Reset out Open drain( internal 75KOhm high) Crystal out Reference 3.3V for Reset Out Panel on/off switch out (Max current driving 1A) Embedded regulator P type BJT control pin out TMDS_TEST Pin; Power-on-latch for host interface type. TMDS power(3.3V) Impedance Match Reference. For External Bypass Capacitor Power for digital PLL(3.3V) Power for multi-phase PLL(3.3V) Test Pin 1;Power-on-latch for MCU crystal location Test Pin 2;Power-on-latch for crystal in frequency Serial control I/F chip select(Open drain) Serial control I/F clock(Open drain) PVCC VCCK ADC Power(1.8V) Video8 Clock ADC vertical sync input 5V tolerance Power from PIN 13 ADC horizontal sync input Adjustable Schmidt trigger 5V tolerance Power from PIN 13 AIC1084-33PM (U701): DC power convert, used to 5v convert 3.3v. - 20 – ViewSonic Corporation MTV512GMV64 (U402): The MTV512M micro-controller is an 8051 CPU core embedded device especially tailored for flat panel display applications. It includes an 8051 CPU core, 768-byte SRAM, 4 channels of 6-bit ADC, 3 external counters/timers, 6 channels of PWM DAC, VESA DDC interface, and a 64K-byte internal program Flash-ROM memory. Circuit Diagram - 21 – ViewSonic Corporation PIN Function Pin No. PLCC QFP NC 1 39 DA0/P5.0 2 40 DA1/P5.1 3 41 DA2/P5.2 4 42 DA3/P5.3 5 43 DA4/P5.4 6 44 DA5/P5.5 7 1 P5.6/HSCL2 8 2 P5.7/HSDA2 9 3 RST 10 4 HSCL1/P3.0/RXD 11 5 HSDA1/P3.1/RXD 13 7 P3.2/INT0 14 8 Name DESCRIPTION No connection PWM DAC output/General purpose I/O (open drain) PWM DAC output/General purpose I/O (open drain) PWM DAC output/General purpose I/O (open drain) PWM DAC output/General purpose I/O (open drain) PWM DAC output/General purpose I/O (open drain) PWM DAC output/General purpose I/O (open drain) General purpose I/O/Slave llC1 SCL2(open drain) General purpose Output/Slave llC1 SCL2(open drain) High Active RESET Slave IIC clock/General purpose I/O/Rxd (open drain) Slave IIC clock/General purpose I/O/Txd (open drain) General purpose I/O/External interrupt 0(Standard 8051) - 22 – ViewSonic Corporation P3.3/INT1 P3.4/T0 P3.5/T1 P7.6/CLKO2 P7.7 X2 X1 VSS P6.0/AD0 P6.1/AD1 P6.2/AD2 P6.3/AD3 P6.4 P6.5 P6.6/CLKO1 P6.7 VSYNC P1.7 P1.6 P1.5 P1.4 P1.3 P1.2 P1.1 9 10 11 12 13 14 15 16 18 19 20 21 22 23 24 25 26 30 31 32 33 34 35 36 P1.0/ET2 15 16 17 18 19 20 21 22 24 25 26 27 28 29 30 31 32 36 37 38 39 40 41 42 43 VCC 44 38 37 General purpose I/O/External interrupt 1(Standard 8051) General purpose I/O/T0 Ext. Counter/Timer 0(Standard8051) General purpose I/O/T1 Ext. Counter/Timer 1(Standard8051) General purpose I/O/Clock out 2 (CMOS) General purpose I/O (CMOS) Crystal Out Crystal In Ground General purpose I/O(COMS)/6-bit ADC channel 0 input General purpose I/O(COMS)/6-bit ADC channel 1 input General purpose I/O(COMS)/6-bit ADC channel 2 input General purpose I/O(COMS)/6-bit ADC channel 3 input General purpose I/O(COMS) General purpose I/O(COMS) General purpose I/OCLKO1(COMS) General purpose I/O(COMS) VSYNC input General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O(Standard 8051/CMOS) General purpose I/O/External Counter/Timer2(Standard 8051/CMOS) 3.3V power TDA7496L (U201): The UTC TDA7496L is a stereo 2W+2W class AB power amplifier, specially designed for high quality sound, TV and Monitor applications. Features of the UTC TDA7496L include linear volume control, Stand-by and mute functions. Pin Function - 23 – ViewSonic Corporation Circuit Diagram LD7552BS (IC901): PWM control, high-voltage startup current. The circuit unit has functions such as over-current protection, over-voltage protection, output short-circuit protection and etc. The function of each pin and the inside circuit diagram are as follows: Pin Name Function 1 2 GND Ground Voltage feedback pin (same as the COMP pin in UC384X), By COMP connecting a photo-coupler to close the control loop and achieve the regulation 3 VCC 4 RT 6 7 8 NC VCC OUT Supply voltage pin This pin is to program the switching frequency. By connecting a resistor to ground to set the switching frequency. Unconnected pin Supply voltage pin Gate drive output to drive the external MOSFET - 24 – ViewSonic Corporation FAN7547A(IC201): The FAN7547A provides all control functions for a current fed push-pull self oscillation type converter, and also contains voltage. Typical operating frequency range is between 30kHz depending on the CCFL(Cold Cathode Fluorescent Lamp) and the transformer’s characteristics: NO. Name 1 GNDT 2 Function Description NO. Name Ground 8 FB Vds Dimming Voltage Input 9 COMP 3 Vref Reference Voltage 10 S/S Soft Start 4 Vms 11 OSC Main Ct 5 Rct 12 Vcc Supply Voltage 6 OLP Dimming Mode Selection Burst Dimming Frequency Set Open Lamp Protection 13 Vcc1 Output Drive Source Voltage 7 SDP Shutdown Protection 14 OUT Output Drive - 25 – ViewSonic Corporation Function Description Feedback Input Error Amplifier Output - 26 – ViewSonic Corporation 5. Adjust Procedure 5.1 ADJUSTMENT CONDITIONS AND PRECAUTIONS 1. Approximately 30 minutes should be allowed for warm up before proceeding. 2. Adjustments should be undertaken only on those necessary elements since most of them have been carefully preset at the factory. 3. ESD protection is needed before adjustment. 5.2 MAIN ADJUSTMENTS NO. 1. 2. 5.3 FUNCTIONS White Balance Geometry DESIGNATION Function Key Function Key ALIGNMENT PROCEDURES Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment. 1. Adjust of White Balance 1.)How to do the Chroma-7120 MEM .Channel setting A、Reference to Chroma 7120 user guide B、Use “ SC” key and “ NEXT” key to modify xyY value and use “ID” key to modify the TEXT description Following is the procedure to do white-balance adjust 2.)Setting the color temp. You want A、MEM.CHANNEL9 ( 9300 color): 9300 color temp. parameter is Wx = 0.283 ±0.02;Wy = 0.298 ±0.02; Y > 190 cd/m2 , B、MEM.CHANNEL10 ( 6500 color): 6500 color temp. parameter is Wx = 0.313±0.02;Wy = 0.329 ±0.02; Y > 260 cd/m2, C、MEM.CHANNEL 11 ( 5400 color): 5400 color temp. parameter is Wx = 0.335±0.02;Wy = 0.350 ±0.02; Y > 210 cd/m2, D、MEM.CHANNEL 12 ( 5000 color): 5000 color temp. parameter is Wx = 0.346±0.02;Wy = 0.359 ±0.02; Y > 210 cd/m2 E、MEM.CHANNEL13 ( SRGB color): SRGB color temp. parameter is Wx = 0.313±0.02;Wy = 0.329 ±0.02; Y > 220 cd/m2, - 27 – ViewSonic Corporation 3.)Into factory mode of VA712b-2 A、First Power off, then press Switch 2 button along with press Power button will activate the factory mode, then MCU will do AUTO LEVEL automatically. Meanwhile press MENU the OSD screen will located at LEFT TOP OF PANEL. 4.)Bias adjustment : Set the Contrast to 70 Adjust the Brightness to 100. 5.)Gain adjustment : Move cursor to “-F-” and press MENU key A、Adjust 9300 color-temperature (1)、Switch the Chroma-7120 to RGB-Mode (with press “MODE” button ) (2)、Switch the MEM. channel to Channel 9 ( with up or down arrow on Chroma 7120 ) (3)、The LCD-indicator on Chroma 7120 will show x = 0.283 ±0.02, y =0.298 ±0.02, Y > 250 cd/m2 (4)、Adjust the RED of color1 on factory window until chroma 7120 indicator reached the value R=100 (5)、Adjust the GREEN of color1 on factory window until Chroma 7120 indicator reached the value G=100 (6)、Adjust the BLUE of color1 on factory window until Chroma 7120 indicator reached the value B=100 (7)、Repeat above procedure ( item 4,5,6) until Chroma 7120 RGB value meet the tolerance =100±5 B、Adjust 6500 color-temperature (1)、Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2)、Switch the MEM .channel to Channel 10( with up or down arrow on Chroma 7120 ) (3)、The LCD-indicator on Chroma 7120 will show x = 0.313 ±0.02, y = 0.329 ±0.02, Y>260 cd/m2 (4)、Adjust the RED of color3 on factory window until Chroma 7120 indicator reached the value R=100 (5)、Adjust the GREEN of color3 on factory window until Chroma 7120 indicator reached the value G=100 (6)、Adjust the BLUE of color3 on factory window until Chroma 7120 indicator reached the value B=100 (7)、Repeat above procedure ( item 4,5,6) until Chroma 7120 RGB value meet the tolerance =100±5 - 28 – ViewSonic Corporation C、Adjust 5400 color-temperature (1) Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2)、Switch the MEM .channel to Channel 11( with up or down arrow on Chroma 7120 ) (3)、The LCD-indicator on Chroma 7120 will show x = 0.335 ±0.02, y = 0.350 ±0.02, Y>210 cd/m2 (4)、Adjust the RED of color3 on factory window until chroma 7120 indicator reached the value R=100 (5)、Adjust the GREEN of color3 on factory window until Chroma 7120 indicator reached the value G=100 (6)、Adjust the BLUE of color3 on factory window until Chroma 7120 indicator reached the value B=100 (7)、Repeat above procedure ( item 4,5,6) until Chroma 7120 RGB value meet the tolerance =100±5 D、Adjust 5000 color-temperature (1) Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2)、Switch the MEM .channel to Channel 11( with up or down arrow on Chroma 7120 ) (3)、The LCD-indicator on Chroma 7120 will show x = 0.346 ±0.02, y = 0.359 ±0.02, Y>210 cd/m2 (4)、Adjust the RED of color3 on factory window until chroma 7120 indicator reached the value R=100 (5)、Adjust the GREEN of color3 on factory window until Chroma 7120 indicator reached the value G=100 (6)、Adjust the BLUE of color3 on factory window until Chroma 7120 indicator reached the value B=100 (7)、Repeat above procedure ( item 4,5,6) until Chroma 7120 RGB value meet the tolerance =100±5 E、Adjust SRGB color-temperature (1)、Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2)、Switch the MEM .channel to Channel 10( with up or down arrow on chroma 7120 ) (3)、The LCD-indicator on chroma 7120 will show x = 0.313 ±0.02, y = 0.329 ±0.02, Y>220 cd/m2 (4)、Adjust the RED of color3 on factory window until Chroma 7120 indicator reached the value R=100 (5)、Adjust the GREEN of color3 on factory window until Chroma 7120 indicator reached the value G=100 (6)、Adjust the BLUE of color3 on factory window until Chroma 7120 indicator reached the value B=100 (7)、Repeat above procedure ( item 4,5,6) until Chroma 7120 RGB value meet the tolerance =100±5 - 29 – ViewSonic Corporation F、Press reset key and Turn the Power-button “off to on” to quit from factory mode. 2. Geometry 1).Set cross-hatch pattern and preset timing as timing table listed. 2).Change to each mode in turn and wait for the monitor finish auto-alignment and save press before change to next mode. 3).Until all of modes are adjusted, exit OSD menu and press POWER OFF to exit factory mode. 5.4 Factory Defaults Item Defaults Item Defaults Contrast 70% OSD H. Position 50% Brightness 100% OSD V. Position 50% Volume 50% OSD Time Out 15 Sec Color Temperature 6500K Resolution Notice Enable Sharpness 33% OSD background Enable 720X400/640X400 720X400 5.5 Function Test 1 Product: 17” LCD Monitor 2 Test Equipment: Color Video Signal & Pattern (or PC with SXGA resolution and a sound card) 3 Test Condition: Before function test and alignment, each LCD Monitor should be warmed up for at least 30 minutes with the following conditions: (a)In room temperature, (b) With full-white screen, RGB, and Black (c) With cycled display modes, 640*480 (H=43.27kHz, V=85Hz) 800*600 (H=53.7kHz, V=85Hz) 1024*768 (H=68.67kHz, V=85Hz) 1280*1024 (H=79.97kHz, V=75Hz) - 30 – ViewSonic Corporation 4 Test Display Modes & Pattern Compatible Modes Analog 640 x 350 @ 70Hz, 31.5kHz 640 x 400 @ 70Hz, 31.5kHz 640 x 480 @ 60Hz, 31.5kHz 640 x 480 @ 67Hz, 35.0kHz 640 x 480 @ 72Hz, 37.9kHz 640 x 480 @ 75Hz, 37.5kHz 720 x 400 @ 70Hz, 31.5kHz 800 x 600 @ 56Hz, 35.1kHz 800 x 600 @ 60Hz, 37.9kHz 800 x 600 @ 75Hz, 46.9kHz 800 x 600 @ 72Hz, 48.1kHz 832 x 624 @ 75Hz, 49.7kHz 1024 x 768 @ 60Hz, 48.4kHz 1024 x 768 @ 70Hz, 56.5kHz 1024 x 768 @ 72Hz, 58.1kHz 1024 x 768 @ 75Hz, 60.0kHz 1280 x 1024 @ 60Hz, 63.4kHz 1280 x 1024 @ 75Hz, 79.97kHz 1280x 720 @ 60Hz, 45kHz Digital 640 x 350 @ 70Hz, 31.5kHz 640 x 400 @ 70Hz, 31.5kHz 640 x 480 @ 60Hz, 31.5kHz 640 x 480 @ 67Hz, 35.0kHz 640 x 480 @ 72Hz, 37.9kHz 640 x 480 @ 75Hz, 37.5kHz 720 x 400 @ 70Hz, 31.5kHz 800 x 600 @ 56Hz, 35.1kHz 800 x 600 @ 60Hz, 37.9kHz 800 x 600 @ 75Hz, 46.9kHz 800 x 600 @ 72Hz, 48.1kHz 832 x 624 @ 75Hz, 49.7kHz 1024 x 768 @ 60Hz, 48.4kHz 1024 x 768 @ 70Hz, 56.5kHz 1024 x 768 @ 72Hz, 58.1kHz 1024 x 768 @ 75Hz, 60.0kHz 1280 x 1024 @ 60Hz, 63.4kHz 1280 x 1024 @ 75Hz, 79.97kHz 1280x 720 @ 60Hz, 45kHz Function Test Display Pattern Item 1 2 Test Content Pattern Frequency & Fine Line Moire Tracking Contrast/Bright 16 Gray Scale ness Horizontal&Vertical Thickness 3 Boundary 4 RGB Color RGB Color Intensities Performance 5 Screen Uniformity Flicker 6 Dead Pixel/Line White Screen & Dark Screen 7 White Balance White & Black Pattern Remark Figure 1 Figure 2 Figure 3 Figure 4,5,6 Should be compliant Figure 7 with the spec. & Full White - 31 – ViewSonic Corporation Specification Eliminate visual wavy noise. 16 gray levels sh should be distinguishable. Horizontal and Vertical position of video should be adjustable to be within the screen frame. Contrast of each R, G, B, color should be normal. The numbers of dead pixels should be Figure 7,8 compliant with the spec. The screen must have the pure white and black Figure 9 pattern, no other color. Fine Line Morie Pattern (Figure1) Gray Scale Pattern (Figure2) Horizontal & Vertical Thickness Pattern (Figure 3) R. Color Pattern (Figure 4) G. Color Pattern (Figure 5) B. Color Pattern (Figure 6) - 32 – ViewSonic Corporation Full White Pattern (Figure 7) Dark Screen Pattern (Figure 8) Black-White Pattern (Figure 9) 4.3 Function Test and Alignment Procedure All Modes Reset You should do “All Mode Reset” (Refer to Chapter III-3. Hot Keys for Function Controls) first. This action will allow you to erase all end-user’s settings and restore the factory defaults. Auto Image Adjust Please select and enter “Auto Image Adjust” function on Main Menu to see if it is workable. The “Auto Image Adjust” function is aimed to offer a better screen quality by built-in ASIC. For optimum screen quality, the user has to adjust each function manually. Firmware Test Pattern: Burn In Mode (Refer to Chapter III-3. Hot Keys for Function Controls) Make sure the F/W is the latest version. DDC Test Pattern: EDID program - 33 – ViewSonic Corporation Make sure it can pass test program. Fine Tune and Sharpness Test Signal: 1280*1024@60Hz Test Pattern: Line Moire Pattern Check and see if the image has noise and focus performs well. Eliminate visual line bar. If not, readjust by the following steps: (a)Select and enter “Fine Tune” function on “Manual Image Adjust” to adjust the image to eliminate visual wavy noise. (b)Then, select and enter “Sharpness” function to adjust the clarity and focus of the screen image. Boundary Test Signal: 1280*1024@60Hz Test Pattern: Horizontal & Vertical Line Thickness Pattern Check and see if the image boundary is within the screen frame. If not, readjust by the following steps: (a)Select and enter “Manual Image Adjust” function on OSD Main Menu. (b)Then, select and enter “Horizontal Size” or “Horizontal/Vertical Position” function to adjust the video boundary to be full scanned and within screen frame. White Balance Test Signal: 640*480@60Hz Test Pattern: White and Black Pattern 1.5.8 R, G, B, Colors Contrast Test Signal: 1280*1024@60Hz Test Pattern: R, G, B, Color Intensities Pattern and 16 Gray Scale Pattern - Check and see if each color is normal and distinguishable. - If not, please return the unit to repair area. Screen Uniformity and Flicker Test Signal: 1280*1024@60Hz Test Pattern: Full White Pattern - Check and see if it is in normal condition. 1.5.10 Dead Pixel and Line Test Signal: 1280*1024@60Hz Test Pattern: Dark and White Screen Pattern - Check and see if there are dead pixels on LCD panel with shadow gauge and filter film. - The total numbers and distance of dead pixels should be compliant with the spec. Mura Test Pattern: White, RGB, Black, & Grey Test Tool: 10% ND Filter - Check if the Mura can pass 10% ND Filter. Audio Test Signal: Voice signal (optional, depend on model) Test Pattern: liberty - Make sure there is audio output. - Make sure that audio function (volume 80%) is working without noise and - 34 – ViewSonic Corporation resonance. - Make sure that the sound of right and left speakers are in balance. Check for Secondary Display Modes Test Signal: Analog: 640*350@70Hz; 640*480@60/67/72/75/85Hz; 720*400@70Hz; 800*600@56/60/72/75/85Hz; 832*624@75Hz, 1024*768@60/70/72/75/85Hz; 1280*1024@60/75Hz Digital: 640*350@70Hz; 640*480@60/72/75/85Hz; 720*400@70Hz; 800*600@56/60/72/75/85Hz; 1024*768@60/70/72/75/85Hz; 1152*870@75Hz, 1280*720@60Hz, 1280*1024@60Hz - Normally when the primary mode 1280*1024@60Hz is well adjusted and compliant with the specification, the secondary display modes will also be compliant with the spec. But we still have to check with the general test pattern to make sure every secondary is compliant with the specification. All Modes Reset After final QC step, we have to erase all saved changes again and restore the factory defaults. You should do “All Mode Reset” again. Power Off Monitor Turn off the monitor by pressing “Power” button. - 35 – ViewSonic Corporation 5.6 Firmware Upgrade Procedure When you receive the returned monitor, please check whether the firmware version is the latest. If not, please do the following procedures to upgrade it to the latest version. 1 Equipment Needed - VA712-2/VA712b-2 Monitor - Fixture for Firmware Upgrade - Power Adapter (P/N: 47.58201.001) *1 for Fixture - VGA Cable (P/N: 42.59901.003) *1(Pin 4, 11 should be connected to GND) - PC (Personal Computer) - LPT Cable (P/N: 42.59906.001) *1 - Firmware Upgrade Program - One additional monitor for checking the program execution 2 Setup Procedure 2.1 Connect P1 of Fixture with printer port of PC by LPT Cable. 2.2 Connect P2 of Fixture with VA712-2/VA712b-2 Monitor by VGA Cable. 2.3 Connect Power Cord to VA712-2/VA712b-2 Monitor. 2.4 Connect P3 to the Signal Generator (eg.Chroma2326) for verifying it after the operation being completed. 2.5 Connect PC to the additional monitor. - 36 – ViewSonic Corporation 3 Firmware Upgrade Procedure Step 1. Let VA712-2/VA712b-2 set to be connected with AC cable and VGA cable. Step 2.Execute the MSstar ISP tool. - 37 – ViewSonic Corporation Step 3. Click “Create Security File” button. Open a new window to key in security code. Step 4.Set “Command NO” to 4,and key in security code :“94,94,ac,ca,53” to shown as following, then press “OK” button to close window. - 38 – ViewSonic Corporation Step 5. Click dropdown listbox for MTV type, select the “MTV512M64” viewed on your set. Step 6. Click “Load MCU File” button. Select the object bincode on your corresponding directory. Step 7. Click “确定” button to finish the selection of bincode. - 39 – ViewSonic Corporation Step 8. Select “Auto” optionbutton, then execute the flashing action by clicking the “RUN” button. Step 9. If the flashing F/W has been completed, the message of “Check MCU CRC OK” on the right TextBox means the Host verify ok for the progress of program. - 40 – ViewSonic Corporation Step 10. Unplug and replug power cord of VA712-2/VA712b-2 set and then check the OSD operation and image on srceen. Step 11. At last, do “Memory Recall.” 3.2 Setup Procedure 3.2.1 Connect P2 and monitor of Fixture with VGA ports of VA712-2/VA712b-2 by VGA Cable. 3.2.2 Connect P3 of Fixture with DVI port of VA712b-2 by DVI-DVI Cable. 3.2.3 Connect P1 of Fixture with Printer port of PC by LPT Cable. 3.2.4 Plug Power Adapter to Fixture. 3.2.5 Connect Power Cord to VA712-2/VA712b-2 Monitor. 3.2.6 Connect PC to the additional monitor. JP1: Power Adapter P3:DVI-DVI Cable P2: VGA Cable P1:to LTP Cable - 41 – ViewSonic Corporation 3.3 DDC Key In Procedure Sep1.Select and execute DDC Key In program - 42 – ViewSonic Corporation Sep2:Inpute the S/N and execute “Enter” - 43 – ViewSonic Corporation - 44 – ViewSonic Corporation Sep3:Key the “Enter” and write the data - 45 – ViewSonic Corporation Sep4:If ddc program OK and show “data compare ok” - 46 – ViewSonic Corporation 6. Trouble Shooting Flow Chart - 47 – ViewSonic Corporation 7. Recommended Spare Part List VA712b-2 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 BOM list(T780KCWHKDV3ABP) ViewSonic P/N Ref. P/N AUPC780B3P CBPC780KCWV3P KEPC780KE1P PWPC1742CPV2P 7G 1 S 29 11G6054 1 12G 436 1 12G8394 1 15G5786 1 15G8239 1 15G8267 1 15G8269 1 19G6014 1 23G3178709 4A 23G3178709 6A 33G4942 X2 B 33G4943 1 33G4944 1 34G1750A4Z B 34G1751 4Z B 34G1752 4Z B 34G1753 4Z B 34G1754 4Z B 37G 552 1 40G 45760819A 40G 459709 1B 40G 459709 5A 40G 581 26704 40G 58162435A 40G 58170918D 40G 970709 8A 40G457B709 1A 40G581B709 2B 40G581B709 3A 40G581B709 4A 41G7801709 6A ViewSonic Corporation Description AUDIO BOARD CONVERSION BOARD KEY BOARD POWER BOARD WOODEN PALLET PIN CONNECTOR VESA RUBBER FOOT PORON VRSA BRACKET Kensington bracket MAIN FRAEM HINGE BKT 打包固定夹 VSC17-LCD FRONT LOGO BIRD LOGO (E015-006) FONCTION BUTTON POWER LENS VSC LOGO BEZEL REAR COVER DECO COVER STAND BASE HINGE 机种标签 CARTON LABEL HI-POT LABEL FOR 17-LCD 唛头纸 FOR CARTON/PALLET MANUAL P/N LABEL PALLET LABEL ID Hg LABEL BLUE STICKER-2 8ms STICKER S/N LABEL QSG - 48 – Location Universal number# Q'ty 1 1 1 1 0.018 4 4 6 1 1 1 1 0.2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0.01 1.05 0.25 1 1 1 1 1 1 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 44G3231502 44G3783 1 44G3783 2 44G6002 S 22 44G6002 S 23 44G9003210 45G 76 28 V3 45G 77 3 45G 88606 45G 88607 45G 88609 B 50G 600 1 W 50G 600 2 50G 600 3 52G 1150 C 52G 1185 52G 1185 24 52G 1206 A 52G 1207 A 52G 1217 VS 52G 1901 A 52G6019 1 52G6020 1 52G8025 11803 52G8025 11804 70G1701709 9B 78G 311 8 L 78G 311 8 R 85G 722 1 89G 173 56 31 89G 728GAA902 89G 728HAA902 89G1748GAADVI 89G1748HAADVI 89G1748LAADVI 89G402A18N IS 89G402A18N LS 95G8014 14 34 95G8014 16926 导电泡棉 EPS(R) EPS(R) PAPER PLATE PAPER PLATE CORNER PAPER PE BAG TRANSPARENT SHEET PE BAG FOR BASE PE BAG EPE COVER 白色机用打包带 HANDLE1 HANDLE2 BLACK TAPE MIDDLE TAPE FOR CARTON TAPE 铝箔胶带 铝箔胶带 铝箔胶带 铝箔胶带 YELLOW TAPE PROTECT FILM MYLAR POWER MYLAR SHIELD CD MANUAL SPEAKER 8OHM 2.5W SPEAKER 8OHM 2.5W MAIN SHIELD AUDIO CABLE SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE POWER CABLE POWER CORD HARNESS 14P-14P 50mm WIRE HARNESS - 49 – ViewSonic Corporation 2 1 1 0.018 0.018 0.071 1 173 1 1 1 74 1 1 4 10 65 3 1 2 2 5 1 1 1 1 1 1 1 1 0 1 1 0 0 0 1 1 1 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 95G8018 30910 M1G 330 4128 M1G 330 4128 M1G1140 6128 M1G1730 6128 M1G1730 6128 M1G1730 6128 M1G1740 12120 Q1G 130 6120 Q1G 330 8128 Q1G 330 8128 Q1G 330 10 47 Q1G1030 8128 Q1G1040 10128 750GLC70A7Q 12 750GLC70A7Q 13 750GLC70A7Q 22 750GLC70A7Q 23 C 44G3783709 1A AUPC780B3P AUPC780A7AIP AUPC780A7SMTP 12G 408 6 33G801714A 51G6002 1 56G 616 1 61G 60222452T 67G 2151097NT 67G 2151097NT 67G215L471 3N 67G215L471 3N 67G215L471 3N 67G215L681 4N 67G215L681 4N 88G 30214K 90G6093 1 AUPC780A7AIP 95G 90 23 95G 90 23 WIRE HARNESS SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW CLAA170EA07Q 17" LCD PAN CLAA170EA07Q 17" LCD PAN CLAA170EA07Q 17" LCD PAN CLAA170EA07Q 17" LCD PAN CARTON AUDIO BOARD AUDIO AI BOARD AUDIO SMT BOARD THERMAL PAD WAFER&PLUG 导热胶 AMPLIFIER IC E-TDA7496L 220KOHM 5% 1/6W 1UF/50V 1UF/50V 470UF/16V 470UF/16V 470UF/16V 680UF 25V 680UF 25V PHONE JACK 5PIN HEAT SINK AUDIO AI BOARD TINCOATEDCOPPER TINCOATEDCOPPER - 50 – ViewSonic Corporation 1 4 4 1 3 3 2 4 2 2 3 1 4 3 1 0 0 0 1 CN202 U201 R212 C209 C210 C205 C207 C208 C201 C202 CN201 J201 J202 1 1 1 1 0.2 1 1 1 1 1 1 1 1 1 1 1 0 0 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 95G 90 23 95G 90 23 95G 90 23 95G 90 23 715G1144 2 SH6403 AUPC780A7SMTP 61L0603102 61L0603102 61L0603183 61L0603183 61L0603203 61L0603203 61L0603204 65G0805101 31 65G0805101 31 65G0805104 326360 65G0805104 326360 65G0805474 226213 65G0805474 226213 CBPC780KCWV3P AIC780KCWV3P 33G801714A 33G801724A H 33G8027 12 33G8027 16 40G 45762412B 44G3231508512 44G3231508513 51G6002 1 67G215L101 4N 67G215L101 4N 67G215L101 4N 67G215L101 4N 67G215L221 4N 67G309V100 3 67G309V100 3 67G309V100 3 67G309V220 3 88G 35315F H TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER PCB AUDIO SMT BOARD CHIPR 1KOHM +-5% 1/10W CHIPR 1KOHM +-5% 1/10W CHIP 18K OHM 1/10W CHIP 18K OHM 1/10W CHIPR 20KOHM +-5% 1/10W CHIPR 20KOHM +-5% 1/10W 200K 0603 CHIP 100PF 50V NPD 0805 CHIP 100PF 50V NPD 0805 DHIP 0.1UF 50V X7R DHIP 0.1UF 50V X7R CHEP 0.47UF 25V X7R 080 CHEP 0.47UF 25V X7R 080 CONVERSION BOARD MAIN BOARD WAFER&PLUG PIN 24P 2.0MM RIGHT ANGL WAFER 2*6P 2.0MM R/A WAFER 16PIN 2.0MM DIP CBPC LABEL 导电泡棉 导电泡棉 导热胶 LOW ESR EC 100UF 25V NCC LOW ESR EC 100UF 25V NCC LOW ESR EC 100UF 25V NCC LOW ESR EC 100UF 25V NCC 220UF/25V Electrolytic CAP Electrolytic CAP Electrolytic CAP 22UF +-20% 16V D-SUB 15PIN - 51 – ViewSonic Corporation J203 J204 J205 J206 0 0 0 0 1 R207 R208 R201 R203 R210 R211 R202 C211 C212 C203 C213 C204 C206 1 1 1 1 1 1 1 1 1 1 1 1 1 CN702 CN403 CN701 CN404 C701 C703 C706 C719 C702 C410 C418 C720 C406 CN401 1 1 1 1 1 1.03 1 1 0.2 1 1 1 1 1 1 1 1 1 1 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 88G 35315F HJ 88G 35424F H 90G6250 1 GP 93G 22 45 AIC780KCWV3P 40G 457624 1B 56G 562116 56G 563 7 56G1125543CA3 56G1133 34 56G1133 34 56G1133 56 57G 417 4 57G 417 4 57G 417 4 57G 417 4 57G 417 6 57G 417 6 57G 417 17 T 57G 763 1 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 61L0603000 D-SUB 15PIN DVID CONN 24P FEMALE 90 散热片 CRYSTAL 24MHz HC-49US MAIN BOARD CPU LABEL RTD2523B-LF PQFP-128 AIC1084-33PM TO-263 MTV512MV PLCC-44 MYSON IC M24C02-WMN6TP IC M24C02-WMN6TP IC M24C16-WMN6TP PMBS3904/PLILIPS PMBS3904/PLILIPS PMBS3904/PLILIPS PMBS3904/PLILIPS PMBS3906 PNP PMBS3906 PNP PZT2907A SOT-223 AO3401L CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W CHIPR 0OHM +-5% 1/10W - 52 – ViewSonic Corporation CN401 CN402 X402 0 1 1 1 U401 U701 U402 U405 U406 U404 Q407 Q701 Q702 Q704 Q404 Q405 Q403 U703 FB409 FB410 FB411 R402 R403 R412 R416 R417 R419 R422 R423 R424 R425 R426 R431 R432 R433 R434 R449 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 61L0603000 61L0603000 61L0603000 61L0603000 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603101 61L0603102 61L0603102 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR CHIPR 0OHM +-5% 1/10W 0OHM +-5% 1/10W 0OHM +-5% 1/10W 0OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 100OHM +-5% 1/10W 1KOHM +-5% 1/10W 1KOHM +-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W 10KOHM+-5% 1/10W - 53 – ViewSonic Corporation R456 R457 R713 R718 R4002 R4003 R4019 R4026 R4027 R4028 R4029 R427 R428 R435 R437 R438 R439 R442 R445 R446 R448 R450 R451 R458 R459 R460 R461 R462 R495 R499 R421 R704 R4017 R467 R468 R469 R470 R471 R489 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252 253 254 255 256 257 258 259 260 261 262 263 264 265 266 267 268 269 270 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603103 61L0603105 61L0603151 61L0603153 61L0603202 61L0603202 61L0603202 61L0603223 61L0603303 61L0603332 61L0603471 61L0603471 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 10KOHM+-5% 1/10W CHIPR 1MOHM+-5% 1/10W CHIPR 150 OHM +-5% 1/10W CHIPR 15K OHM +-5% 1/10W CHIPR 2KOHM+-5%1/10W CHIPR 2KOHM+-5%1/10W CHIPR 2KOHM+-5%1/10W CHIPR 22K OHM +-5% 1/10W CHIP 30K OHM 5% 1/10W CHIP 3.3K OHM 1/10W CHIPR 470OHM+-5%1/10W CHIPR 470OHM+-5%1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W - 54 – ViewSonic Corporation R497 R498 R701 R705 R706 R707 R708 R712 R716 R723 R724 R440 R4001 R407 R441 R452 R453 R4016 R409 R444 R473 R491 R4008 R4010 R4011 R4013 R4022 R4023 R4024 R4025 R408 R410 R411 R415 R464 R465 R466 R476 R477 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 271 272 273 274 275 276 277 278 279 280 281 282 283 284 285 286 287 288 289 290 291 292 293 294 295 296 297 298 299 300 301 302 303 304 305 306 307 308 309 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603472 61L0603513 61L0603682 61L0603750 61L0603750 61L0603750 65G0603100 65G0603100 65G0603100 65G0603100 65G0603100 65G0603100 65G0603102 65G0603102 65G0603102 65G0603102 65G0603102 65G0603102 65G0603102 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 31 31 31 31 31 31 32 32 32 32 32 32 32 32 32 32 32 32 CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 4.7KOHM +-5% 1/10W CHIP 51K OHM CHIP 6.8K OHM 1/10W CHIPR 75OHM+-5%1/10W CHIPR 75OHM+-5%1/10W CHIPR 75OHM+-5%1/10W CHIP 10PF 50V NPO CHIP 10PF 50V NPO CHIP 10PF 50V NPO CHIP 10PF 50V NPO CHIP 10PF 50V NPO CHIP 10PF 50V NPO CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 1000PF 50 X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R - 55 – ViewSonic Corporation R478 R479 R480 R481 R482 R483 R484 R485 R486 R487 R488 R492 R493 R709 R710 R722 R721 R4007 R436 R443 R447 C423 C427 C430 C433 C446 C447 C437 C438 C439 C440 C441 C442 C451 C403 C404 C405 C407 C408 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 310 311 312 313 314 315 316 317 318 319 320 321 322 323 324 325 326 327 328 329 330 331 332 333 334 335 336 337 338 339 340 341 342 343 344 345 346 347 348 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603104 65G0603220 65G0603473 65G0603473 65G0603473 65G0603473 65G0603473 65G0603473 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 32 CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP Chip CHIP CHIP CHIP CHIP CHIP CHIP 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R 0.1UF 50V X7R Cap 22PF 47NF 50V X7R 47NF 50V X7R 47NF 50V X7R 47NF 50V X7R 47NF 50V X7R 47NF 50V X7R - 56 – ViewSonic Corporation C409 C411 C412 C413 C414 C415 C416 C417 C419 C420 C421 C448 C449 C450 C452 C453 C454 C455 C456 C457 C458 C459 C460 C704 C705 C707 C709 C710 C711 C715 C717 C718 C432 C422 C424 C425 C426 C428 C429 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 349 350 351 352 353 354 355 356 357 358 359 360 361 362 363 364 365 366 367 368 369 370 371 372 373 374 375 376 377 378 379 380 381 382 383 384 385 386 387 65G0603473 65G0805105 65G0805105 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 56Z601 71G 59C300 71G 59C300 71G 59C300 93G 64 42 93G 64 42 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 6433P 93G 39S 34 93G 39S 34 93G 39S 34 93G 39S 34 32 12 12 M M M M M M M M P P T T T T CHIP 47NF 50V X7R CHIP CAPACITOR 1UF 16V X CHIP CAPACITOR 1UF 16V X 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM 2.0X1.2 100M=600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM CHIP BEAD 0805 600OHM 0.8X1.6 100M=30OHM 0.8X1.6 100M=30OHM 0.8X1.6 100M=30OHM BAV70 DIODE BAV70 DIODE BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 BAV99 SOT-23 ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B - 57 – ViewSonic Corporation C431 C708 C714 FB401 FB402 FB403 FB404 FB405 FB701 FB702 FB703 FB401 FB402 FB403 FB404 FB405 FB701 FB702 FB703 FB406 FB407 FB408 D423 D424 D404 D405 D406 D407 D408 D409 D410 D411 D412 D413 D414 D401 D402 D403 D415 1 1 1 1 1 1 1 1 1 1 1 0 0 0 0 0 0 0 0 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 388 389 390 391 392 393 394 395 396 397 398 399 400 401 402 403 404 405 406 407 408 409 410 411 412 413 414 415 416 417 418 419 420 421 422 423 424 425 426 93G 39S 34 T 93G 39S 34 T 93G 39S 34 T 93G 39S 34 T 93G 39S 34 T 93G 39S 34 T 93G 39S 34 T 93G1004 4 93G1020 1 S 715G1675 C U1 KEPC780KE1P KEPC780KE1SMTP 33G3802 2H 33G3802 2H 33G801712A H 77G 600 1GCJ 77G 600 1GCJ 77G 600 1GCJ 77G 600 1GCJ 77G 600 1GCJ 77G 600 1GCJ 81G 12 1 GP 95G 90 23 KEPC780KE1SMT 61L0805000 61L0805000 715G1690 D PWPC1742CPV2P PW1742CPV2SMTP 9G6005 1 15G8268 1 33G8021 2D U 33G8021 2D U 33G8021 2D U 33G8021 2D U 33G8021 2D AC 33G8021 2D AC 33G8021 2D AC 33G8021 2D AC ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B ZENER DIODE UDZS5.6B SCHOTTKY DIODE 1A 40V SM GSID PCB BOARD KEY BOARD KEPC BOARD WAFTER WAFTER PIN HEADER 2*6 R/A 轻触开关 轻触开关 轻触开关 轻触开关 轻触开关 轻触开关 LED GP32032ME/R003-50-ZY TINCOATEDCOPPER P KEPC BOARD Chip Resistors 0OHM Chip Resistors 0OHM KEPC POWER BOARD POWER BOARD FOR SMT PIN FOOT AC LOCK BKT CON.2PR/A CON.2PR/A CON.2PR/A CON.2PR/A WAFER WAFER WAFER WAFER - 58 – ViewSonic Corporation D416 D417 D418 D419 D420 D421 D422 D701 D702 CN002 CN003 CN006 SW001 SW002 SW003 SW004 SW005 SW006 DP2 J001 FB001 FB002 W901 CN201 CN202 CN203 CN204 CN201 CN202 CN203 CN204 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 0 0 0 1 1 1 1 427 428 429 430 431 432 433 434 435 436 437 438 439 440 441 442 443 444 445 446 447 448 449 450 451 452 453 454 455 456 457 458 459 460 461 462 463 464 465 40G 45762412B 51G 6 4503 56G 139 3A 56G 139 3B 57G 417 11 57G 417 11 57G 761 7 57G 761 7 57G 763 12 57G 763 13 61G 58080 WT 61G152M338 64 63G 107474 HS 63G 10747410S 63G210J3342B2 63G211J334 AB 65G 3J1206EM 65G 3J1206EM 65G 3J1206EM 65G 3J1206EM 65G 3J1206ET 65G 3J1206ET 65G 3J1206ET 65G 3J1206ET 65G305M1022BJ 65G305M1022BJ 65G305M1022BM 65G305M1022BM 65G305M1022BP 65G305M1022BP 65G306M2222BM 65G306M2222BP 67G215D471 4K 67G215D471 4K 67G215H102 3N 67G215L102 4N 67G215L102 4N 67G215L471 4N 67G215L471 4N GP CBPC LABEL RTV 胶 PC123Y22FZOF PC123Y82FZOF KTC5103L-Y-U/P IPAK KTC5103L-Y-U/P IPAK TRANSISTOR KTD1691/P TRANSISTOR KTD1691/P AOU401L TO-251 AOU417 TO251-3L NTCR 0.33 OHM 5% 2W X2 CAP. 0.47UF 0.47UF +-10% 250VAC 0.33uF 250V PMS TAIYANG 0.33UF 5% 160V 12PF 5% SL 3KV MURATA 12PF 5% SL 3KV MURATA 12PF 5% SL 3KV MURATA 12PF 5% SL 3KV MURATA 12PF 5% SL 3KV TDK 12PF 5% SL 3KV TDK 12PF 5% SL 3KV TDK 12PF 5% SL 3KV TDK 1000PF Y2 400V 20% BY JN 1000PF Y2 400V 20% BY JN 100PF Y2 250V 20% BY MUR 100PF Y2 250V 20% BY MUR Y2 1000PF M 250VAC Y5P Y2 1000PF M 250VAC Y5P 2200PF +-20% 250V AC 2200PF Y1 400 20% BY UK LOW ESR EC 470UF 25V LOW ESR EC 470UF 25V KY16VB1000M-1 10*20 LOW ESR 1000UF 25V LOW ESR 1000UF 25V 470UF25V KY25VB470-M-L 1 470UF25V KY25VB470-M-L 1 - 59 – ViewSonic Corporation IC902 IC902 Q206 Q207 Q206 Q207 Q201 Q201 NR901 R916 C900 C900 C211 C211 C205 C210 C214 C215 C205 C210 C214 C215 C901 C902 C901 C902 C901 C902 C932 C932 C202 C925 C923 C922 C924 C202 C925 1 1 1 0 1 1 0 0 0 1 1 1 1 0 0 1 0 0 0 0 1 1 1 1 0 0 1 1 0 0 1 0 1 1 0 0 0 0 0 466 467 468 469 470 471 472 473 474 475 476 477 478 479 480 481 482 483 484 485 486 487 488 489 490 491 492 493 494 495 496 497 498 499 500 501 502 503 504 67G215S10115K 67G215S10115N 67G215S102 3K 67G215S102 4K 67G215S102 4K 67G215S471 3K 67G215Y471 3N 73G 253 91 L 73G 253 91 L 73G 253 91 LS 73G 253 91 LS 73G 253173 YS 73L 174 40 LG 73L 174 40 TG 73L 174 40LSG 73L 174 50 LH 73L 174 50LSH 80GL17T 30 YS 80GL17T 30 YS 80GL17T 31 L 80GL17T 31 N 87G 501 32 S 93G 50460 13 93G 50460502 93G1100 1052T 93G3006 1 95G8014 12 42 705G 780 57V1P 705G 780 57V2P 705G 780 57V3P PW1742CPV2SMTP PW1742CPV2AIP 56G 379 52 56G 660 1 57G 417 4 57G 417 4 57G 417 6 57G 417 12 T 57G 417 12 T LOW ESR EC 100uF 450V 1000/450PAG450VB100M-L 1 ED1000UF 16V ED1000UF 25V ED1000UF 25V LOW ESR EC.470UF 16V 470UF 16V KY16VB470M-L 8 CHOKE BY LI TA CHOKE BY LI TA CHOKE COIL CHOKE COIL 47 uH +-10% CHOKE COIL LINE FILTER LINE FILTER LINE FILTER LINE FILTER LINE FILTER X'FMR YSTDA500280G X'FMR YSTDA500280G X'FMR PT-004433-3 X'FMR AC SOCKET KBP206G 2A 600V BRIDGE KBP206G 2A 800V BA159GPT DO-41 DIODE 1A DIODE 31DQ06FC HARNESS 10P-12P 100mm R909 组件 Q900 组件 D920 组件 POWER BOARD FOR SMT POWER BOARD FOR AI LD7552BS SOP-8 FAN7547MX SOIC-14 PMBS3904/PLILIPS PMBS3904/PLILIPS PMBS3906 PNP 2N3904S-RTK/PS SOT-23 2N3904S-RTK/PS SOT-23 - 60 – ViewSonic Corporation C903 C903 C923 C922 C924 C926 C926 L921 L922 L921 L922 L201 L902 L902 L902 L901 L901 PT201 PT202 T901 T901 CN901 DB901 DB901 D900 D921 CN902 IC901 IC201 Q204 Q208 Q205 Q204 Q208 1 0 1 1 1 1 0 1 1 0 0 1 0 0 1 1 0 1 1 1 0 1 1 0 1 1 1 1 1 1 1 1 1 1 1 1 0 0 505 506 507 508 509 510 511 512 513 514 515 516 517 518 519 520 521 522 523 524 525 526 527 528 529 530 531 532 533 534 535 536 537 538 539 540 541 542 543 57G 417 13 57G 760 4 57G 760 5 57G 760 4B 57G 760 5B 61L0805102 61L0805102 61L0805102 61L0805102 61L0805102 61L0805102 61L0805102 61L0805103 61L0805103 61L0805103 61L0805103 61L0805103 61L0805103 61L0805104 61L0805104 61L0805152 61L0805152 61L0805154 61L0805221 61L0805223 61L0805240 61L0805242 61L0805242 61L0805303 61L0805330 61L0805333 61L0805360 61L0805392 61L0805471 61L0805473 61L0805513 61L0805563 61L0805683 61L0805683 T 1F 2F 1F 2N3906S-RTK/PS SOT-23 DTA144WKA DTC144WKA PDTA144WK SOT 346 PDTC144WK SOT 346 CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 1K OHM +-5% 1/8W CHIPR 10KOHM+-5%1/8W CHIPR 10KOHM+-5%1/8W CHIPR 10KOHM+-5%1/8W CHIPR 10KOHM+-5%1/8W CHIPR 10KOHM+-5%1/8W CHIPR 10KOHM+-5%1/8W CHIPR 100K OHM +-5% 1/8W CHIPR 100K OHM +-5% 1/8W CHIPR 1.5KOHM +-5% 1/8W CHIPR 1.5KOHM +-5% 1/8W CHIP 150KOHM 5% 1/8W CHIPR 220 OHM +-5% 1/8W CHIPR 22K OHM+-5% 1/8W 0 CHIPR 2.4KOHM +-1% 1/8W CHIP 2.4KOHM 1% 1/8W CHIP 2.4KOHM 1% 1/8W CHIP 30K OHM CHIP 33KOHM 1/8W/1% CHIP 33KOHM 1% 1/8W CHIP 3.6KOHM 1/8W 1% CHIP 3.9K OHM 1/10W CHIPR 470 OHM +-5% 1/8W CHIPR 47K OHM +-5% 1/8W CHIP 51KOHM 1/8W CHIP 56K OHM 5% 1/10W CHIPR 68K OHM +-5% 1/8W CHIPR 68K OHM +-5% 1/8W - 61 – ViewSonic Corporation Q205 Q202 Q203 Q202 Q203 R214 R217 R222 R223 R913 R925 R927 R224 R225 R226 R227 R914 R915 R911 R919 R213 R216 R215 R206 R211 R929 R201 R208 R221 R926 R220 R924 R928 R210 R209 R212 R219 R207 R218 0 0 0 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 544 545 546 547 548 549 550 551 552 553 554 555 556 557 558 559 560 561 562 563 564 565 566 567 568 569 570 571 572 573 574 575 576 577 578 579 580 581 582 61L0805753 61L1206000 61L1206101 61L1206229 61L1206334 61L1206334 61L1206334 61L1206334 61L1206434 61L1206434 61L1206434 61L1206514 61L1206514 61L1206514 65G0805102 65G0805103 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805104 65G0805105 65G0805105 65G0805221 65G0805222 65G0805222 65G0805222 65G0805222 65G0805223 65G0805224 65G0805224 65G0805472 65G0805473 31 22 22 22 22 22 22 22 22 32 32 32 32 22 22 22 32 32 32 32 22 22 22 32 32 75K 1/8W CHIPR 0OHM+-5% 1/4W CHIP 100 OHM 5% 1/4W CHIP 2.2OHM 5% 1/8W 330K 1/4W 330K 1/4W 330K 1/4W 330K 1/4W CHIPR 430K 1206 1/4W 5% CHIPR 430K 1206 1/4W 5% CHIPR 430K 1206 1/4W 5% CHIPR 510KOHM +-5% 1/4W CHIPR 510KOHM +-5% 1/4W CHIPR 510KOHM +-5% 1/4W 1000PF 50V NPO CHIP 0.01UF 25V X7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 25VX7R 0805 CHIP 0.1UF 50V X7R 0805 CHIP 0.1UF 50V X7R 0805 CHIP 0.1UF 50V X7R 0805 CHIP 0.1UF 50V X7R 0805 CHIP 1UF 25V X7R 0805 CHIP 1UF 25V X7R 0805 CHIP 220PF 25V X7R 0805 2200PF/50V/0805/X7R 2200PF/50V/0805/X7R 2200PF/50V/0805/X7R 2200PF/50V/0805/X7R E65 E65 E65 4700PF/50V SMD 47NF +-10% 50V - 62 – ViewSonic Corporation R918 F902 R917 R910 R228 R900 R901 R902 R903 R904 R905 R906 R907 R908 C209 C220 C201 C203 C204 C206 C208 C213 C908 C905 C927 C930 C931 C217 C218 C907 C221 C222 C223 C224 C934 C207 C216 C212 C219 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 583 584 585 586 587 588 589 590 591 592 593 594 595 596 597 598 599 600 601 602 603 604 605 606 607 608 609 610 611 612 613 614 615 616 617 618 619 620 621 93G 60264 93G 60264 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432S 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 6432V 93G 39S 25 T 93G 39S 38 T 93G 39S 40 T B340A DO-214AC B340A DO-214AC 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE 1N4148W DIODE DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 DIODE LL4148 GS08 RLZ5.1B ROHM PTZ9.1B ROHM RLZ13B ROHM - 63 – ViewSonic Corporation D201 D204 D202 D203 D205 D206 D207 D208 D209 D210 D211 D212 D213 D214 D215 D216 D217 D922 D923 D202 D203 D205 D206 D207 D208 D209 D210 D211 D212 D213 D214 D215 D216 D217 D922 D923 ZD922 ZD920 ZD921 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1 1 1 622 623 624 625 626 627 628 629 630 631 632 633 634 635 636 637 638 639 640 641 642 643 644 645 646 647 648 649 650 651 652 653 654 655 656 657 658 659 660 93G3004 4 93G3004 4 PW1742CPV2AIP 6G 31502 56G 158 10 T 56G 158 10 T 56G 158 12 56G 158 12 61G 17210052T 61G 17218252T 61G 17218252T 61G 17218252T 61G 17218252T 61G 17222152T 61G 20747052T 61G 20747052T 65G 1K152 1T 65G 1K152 1T 65G517K102 5T 65G517K102 5T 67G 2152207NT 67G 2152207RT 84G 56 1 93G1020 752T 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 GP DIODE RB050L-40 DIODE RB050L-40 POWER BOARD FOR AI 1.5MM RIVET IC AZ431AZ-AE1 TO-92 IC AZ431AZ-AE1 TO-92 KIA431A-AT/P TO-92 IC KIA431A-AT/P TO-92 IC 10OHM 5% 1/4W 1.8KOHM 5% 1/4W 1.8KOHM 5% 1/4W 1.8KOHM 5% 1/4W 1.8KOHM 5% 1/4W 220OHM 5% 1/4W 47 OHM 1/2W 47 OHM 1/2W 1500PF +/-10% 1KV Y5P 1.5NP 1KV 25F +-10% 1000PF 10% Y5P 500V 1000PF 10% Y5P 500V 22UF/50V 22UF +-20% 50V FUSE 2A 250V BY WICKMANN UF4003PT DO-41 DIODE 1A TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER - 64 – ViewSonic Corporation D201 D204 0 0 IC903 IC921 IC903 IC921 R912 R202 R203 R204 R205 R922 R920 R921 C904 C904 C920 C921 C906 C906 F901 D901 J201 J202 J203 J204 J205 J206 J207 J208 J209 J210 J211 J212 J213 J214 J215 15 0 0 1 1 1 1 1 1 1 1 1 1 1 0 1 1 1 0 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 661 662 663 664 665 666 667 668 669 670 671 672 673 674 675 676 677 678 679 680 681 682 683 684 685 686 687 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 95G 90 23 715G1686 F 705G 780 57V1P 61G152M10458G 96G 29 6 705G 780 57V2P 51G 200 1 57G 667 30 57G 724 11 90G6264 1 M1G1730 8128 705G 780 57V3P 51G 200 1 90G6264 1 93G 60238 93G 60239 M1G1730 8128 TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER TINCOATEDCOPPER PCB R909 组件 100K OHM 5% 2W SHRINK TUBE UL/CSA Q900 组件 散热油 2SK2645-54MR TO-220F STP9NK65ZFP TO-220FP MOS HEAT SINK SCREW D920 组件 散热油 HEAT SINK DIODE 10A 150V FCH10A15G DIODE FME-210B TO-220 SCREW - 65 – ViewSonic Corporation J216 J217 J218 J219 J220 J221 J222 J901 J902 J903 J904 1 1 1 1 1 1 1 1 1 1 1 1 R909 1 1 Q900 Q900 D920 D920 2 0 1 1 1 2 1 0 1 1 8. Exploded Diagram And Spare Parts List - 66 – ViewSonic Corporation - 67 – ViewSonic Corporation 5.7 Packing For Shipping - 68 – ViewSonic Corporation Packing Part List ITEM 1 DESCRIPITON PART NUMBER Q’TY CARTON J44G3783709 1C 1 HANDLE1 50G 600 2 1 HANDLE2 50G 600 3 1 3 PE BAG 45G 76 28 V3 1 4 CD MANUAL 70G1701709 9B 1 5 QSG 41G7801709 6A 1 6 EPE COVER 45G 1 7 MONITOR T780KCWHKDV3ABP 1 8 EPE COVER 45G 88609 1 9 PE BAG 45G 88607 10 EPS 11 AUDIO CABLE 89G 173 56 31 1 12 POWER CORD 89G402A18N LS 1 13 SIGNAL CABLE 89G 725HAA902 1 14 BASE 34G1754 4Z B 1 2 B 1 44G3783 1 1 44G3783 2 1 - 69 – ViewSonic Corporation 88606 9. Disassemble Process 9.1 Units Disassemble Process 9.1.1 Tools Glove Big cross screwdriver Small cross screwdriver Prize equipment or abandoned IC card Screw box Cushion Six angle sleeve spanner 9.1.2 Disassemble process 1、 Tide up the worktable, spread straight cushion, put the monitor on it, the front side adown.(Picture 1, 2) 2、 Disassemble the 4 screws that fix the stand, remove the stand..(Picture 3, 4) 3、 Disassemble the fix screws of the back cover.(Picture 5) 4、 Use equipment or abandoned IC card to prize up the bezel through the bottom flute, as showed in the following the picture 6,7, and rip up the back cover downwards.( as showed in the following the picture 8,9,10) 5、 Disassemble the 4 screw M3*6MM through six angle sleeve spanner, showed in the following picture 11. 6、 Disassemble the 4 fixed screws in the shield, remove the shield as the direction arrowhead showed, refer to the following picture 12. 7、 Disassemble the 4 screws and 4 pins of the PWPC board, remove the PWPC board.(symbolized the following picture 13 with red color) 8、 Disassemble the 3 screws and 4 pins of the main board, remove the main board. (symbolized the following picture 13 with blue color) 9、 Disassemble the 2 screws of the audio board, remove the audio board. (symbolized the following picture 13 with green color) 10、 Disassemble the 3 screws and connect pins of the Key board, remove the Key board, refer to the following picture 14,15 . 11、 Disassemble the 2 fixed screws of the main frame, and remove the bezel, as showed in the following the picture 16,17. 12、 Disassemble the 2 fixed screws of the panel, remove the main frame, as showed in the following the picture 18,19,20. Do not damage the cable of the panel. 13、 That’s all. The disassemble process of the unit is over. - 70 – ViewSonic Corporation 9.1.3 Show pictures: (Picture 1) (Picture 2) (Picture 3) (Picture 4) (Picture 5) (Picture 6) - 71 – ViewSonic Corporation (Picture 7) (Picture 8) (Picture 9) (Picture 10) (Picture 11) (Picture 12) - 72 – ViewSonic Corporation (Picture 13) (Picture 14) (Picture 15) - 73 – ViewSonic Corporation (Picture 16) (Picture 17) (Picture 18) (Picture 19) (Picture 20) - 74 – ViewSonic Corporation 10. Block Diagram - 75 – ViewSonic Corporation 11. Schematic Diagram 11.1 Power VCC+5V SMAL140 VCC+5V +12V CN701 1 3 5 7 9 11 U702 NC / AP1117 1.8V 3 2 VIN VOUT GS1D TO-263 BL_ON_OFF BL_ADJ 2 4 6 8 10 12 D702 +5V VCC+5V U701 3 C701 + 100uF/25V C702 C704 + CONN VIN 1 470uF/16V C719 + +3.3V VOUT 2 ADJ AIC1084-33PM 0.1uF +3.3V C705 100uF/25V 0.1uF DEL R702,R703 C706 + C707 0.1uF 100uF/25V +3.3V 3.3V_Vd C703 + 1.8DVCC GN D +12V 1 D701 100uF/25V DGND +5V BL_ADJ FB702 600 OHM R704 1K 1/16W R701 10K 1/16W +5VA R705 10K 1/16W Q701 PMBS3904 VOL_ADJ OUT_L+ OUT_L- +5V BL_ON_OFF OUT_L+ OUT_L- 1 3 5 7 9 11 13 2 4 6 8 10 12 14 C R708 NC / 1K 1/16W R709 220 1/16W RTD_1.8DVCC FB703 CN702 BRIGHTNESS C708 1uF/16V 0805 ADC_1.8AVCC +12V +5V +12VA 2N3904 2N3906 B 600 OHM R706 10K 1/16W R707 10K 1/16W OUT_R+ OUT_RC709 C710 0.1uF 0.1uF STDBY MUTE OUT_R+ OUT_R- E R710 4.7K 1/16W Q702 C711 +5V BACKLIGHT PMBS3904 10K 1/16W 100uF/25V C716 R722 4.7K 1/16W C718 0.1uF U703 51K 1/16W Q704 C717 PMBS3904 0.1uF +3.3V +5V C714 1uF/16V 0805 0.1uF 10K 1/16W PANEL_PW R717 R718 NC 0 1/16W C715 Q703 NC 0.1uF B R713 0 1/16W R714 NC VOLUME AO3401L + C720 10uF/16V Title R724 10K 1/16W Size Date: - 76 – ViewSonic Corporation R711 NC C C713 + R721 R712 10K 1/16W VOL_ADJ delete R715,R720,C712 R716 R723 FB701 600 OHM PANEL_POWER +5V E 0.1uF 715G1675-B POWER Sheet Document Number Thursday, July 28, 2005 Rev T1 1 of 4 11.2 MCU CN404 R454 R456 R458 R460 R462 KEY _A LED_GREEN AUTO_KEY RIGHT_KEY POWER_KEY NC 0 1/16W 100 1/16W 100 1/16W 100 1/16W 1 3 5 7 9 11 OUT_L+ 13 OUT_L- 15 OUT_L+ OUT_LC437 C438 C439 2 4 6 8 10 12 14 16 R455 NC R457 0 1/16W R459 100 1/16W R461 100 1/16W R4019 100 1/16W OUT_R+ OUT_R- OUT_R+ OUT_R- C440 KEY _B LED_ORANGE ENTER_KEY LEFT_KEY KEY _C C441 C442C443 C451 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF NC 0.001uF MCU_VCC +3.3V DEL R463,R472 MCU_VCC 4.7K 1/16W 10K 1/16W 10K 1/16W 10K 1/16W 10K 1/16W 10K 1/16W MCU_VCC DEL R490,C444,R474,R475,R496,R494 43 42 41 40 39 38 37 36 P1.0 P1.1 P1.2 P1.3 P1.4 P1.5 P1.6 P1.7 VCC 33 MCU_VCC 32 31 30 29 28 27 26 25 24 DDC_WP M512_XOUT EEPROM_WP DVI_DET R442 100 1/16W R497 10K 1/16W R4015 NC R498 10K 1/16W KEY -B STDBY MUTE NC NC P6.7 P6.6/CLK0 P6.5 P6.4 P6.3/AD3 P6.2/AD2 P6.1/AD1 P6.0/AD0 R489 10K 1/16W 35 12 HDA1/TX/P3.1 HCL1/RX/P3.0 VSS 1/16W 1/16W 1/16W 1/16W XTAL1 13 11 100 100 100 100 44 10 R4002 R4003 R4004 R4005 VSY NC MTV512 P3.2/INT0 P3.3/INT1 P3.4/T0 P3.5/T1 P7.6/CLKO P7.7 22 C DDC_SDA DDC_SCL TXD RXD LED_GREEN 14 15 16 17 18 19 NC 21 IICSCL IICSDA AUTO_KEY CONNECT Q405 PMBS3906 B R492 4.7K 1/16W R493 4.7K 1/16W R495 100 1/16W R499 100 1/16W AUTO_KEY R4001 150 1/16W P5.0/DA0 P5.1/DA1 P5.2/DA2 P5.3/DA3 P5.4/DA4 P5.5/DA5 HSCL2/P5.6 HSDA2/P5.7 20 R491 470 1/16W RST BRIGHTNESS ENTER_KEY RIGHT_KEY LEFT_KEY POWER_KEY KEY _C KEY _A MCU_VCC C445 NC 2 3 4 5 6 7 8 9 U402 XTAL2 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W C VOLUME 4.7K 1/16W 4.7K 1/16W R4023 R477 R478 R479 R480 R481 R476 R4013 R482 R483 R484 R485 R4022 R486 Q404 PMBS3906 B LED_ORANGE E BACKLIGHT PANEL_PW SDIO0 3 SDIO1 3 SDIO2 3 RTD_SD3/SDI 3 RTD_SCSB RTD_SCLK MCU_RST 4.7K 1/16W E R473 470 1/16W 4.7K 1/16W MCU_VCC 4.7K 1/16W 4.7K 1/16W R464 R465 R466 R467 R468 R469 R470 R471 +3.3V MCU_VCC MCU_VCC X402 R4008 24MHz +5V R4006 VGA5V KEY -B R4009 NC BAV70 EEPROM_WP IICSCL IICSDA C447 10pF 8 7 6 5 VCC NC WC NC SCL NC SDA VSS 3 R4024 R4027 100 1/16W R4026 100 1/16W C449 0.1uF U405 8 7 6 5 VCC WP SCL SDA A0 A1 A2 GND 1 2 3 4 EDID_WP DDC2_SCL DDC2_SDA 3 R4025 DDC_WP 4.7K 1/16W 4.7K 1/16W 4.7K 1/16W EDID_WP R4016 R487 R488 R4010 4.7K 1/16W R4011 4.7K 1/16W R4028 R4029 22K 1/16W C450 U406 0.1uF 100 1/16W 100 1/16W 8 7 6 5 M24C02WMN6 VCC WP SCL SDA A0 A1 A2 GND M24C02WMN6 1 2 3 4 R4017 10K 1/16W Date: - 77 – Q407 R4018 PMBS3904 NC C452 0.1uF Title Size ViewSonic Corporation 1 2 3 4 M24C16 D424 BAV70 R4014 NC EDID_WP DDC_SCL DDC_SDA C446 10pF 2 1 D423 4.7K 1/16W NC KEY _B BUS_POWER 2 Q406 C448 0.1uF U404 4.7K 1/16W R4007 6.8K 1/16W +5V 1 NC 715L1675-B MCU Sheet Document Number Thursday, July 28, 2005 Rev T1 3 of 4 11.3 Scaler R3.3DVCC FB402 600 OHM +3.3V +3.3V Closed to Scaler C401 NC XO X401 NC/24.576MHz 2 R401 NC C404 C405 0.1uF 0.1uF 0.1uF XI C406 + C407 0.1uF 22uF/16V DGND C402 NC R402 C403 R1.8DVCC 0 1/16W DEL R405,R406 M512_XOUT Closed to Crystal R403 R404 0 1/16W NC W hen RTD 2333, R403= NC/R404 = 0; Otherwise, R403 = 0/R404 = NC +3.3V +3.3V 1.8DVCC FB401 600 OHM R1.8DVCC 1.8DVCC FB403 600 OHM C411 C410 0.1uF 10uF/16V + C412 C413 0.1uF 0.1uF C408 C409 0.1uF 0.1uF +3.3V R408 DGND RXE1- RXE1+ 37 TXO1+ RXE0+ TXO1- RXE0- 39 38 TXO0+ R1.8DVCC DGND 41 40 TXO0- RTD_SD3/SDI 44 43 42 PGND RST_OUT RTD_SCLK RTD_SCSB 45 R3.3DVCC 33VRST_REF 47 46 48 RXE2RXE2+ 34 RXEC- 33 RXEC+ 32 RXE3- 31 RXE3+ 30 RXO0- 29 RXO0+ 28 RXO1- 27 RXO1+ 26 RXO2- 25 RXO2+ TXEC- TXE2+ 36 35 24 TXEC+ TXE2- TXE3- R+/V7 TXE1+ 23 12 R-/V6 22 R1+ SOG/V5 RXOC+ 11 TXE1- RXO3- R1- TXE0+ G+/V4 TXE3+ 10 TXE0- G-/V3 PGND SOG1 TXO3+ NC / RTD2023L B+/V2 21 9 B-/V1 RXO3+ G1+ VCCK 8 SCSB/PWM1/DDCSCL G1- SDIO[3]/PWM2/DDCSDA 7 VCCK B1+ TXO3- BJT_CTRL 6 TXOC+ AHS/V0 PWM2/DDCSDA/SCLK B1- AVS/VCLK TXOC- 20 R428 100 1/16WDDCSDA1 5 TXO2TXO2+ DGND R427 100 1/16WDDCSCL1 AHS1 PLL_GND 19 RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+ PLL_VDD 59 72 83 95 108 BJT_B RXOC- 47 116 60 71 84 96 107 PGND PGND PGND PGND PGND RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ RXOCRXOC+ RXO3RXO3+ BJT_B DDC_SDA 82 81 80 79 78 77 76 75 74 73 4 XI 18 DDC_SCL BR1N / TXE0BR1P / TXE0+ BR2N / TXE1BR2P / TXE1+ BR3N / TXE2BR3P / TXE2+ BG1N / TXECBG1P / TXEC+ BG2N / TXE3BG2P / TXE3+ AVS1 XO 17 B1- / V7 B1+ / V6 G1- / V5 G1+ / V4 SOG1 / V3 R1- / V2 R1+ / V1 ADC_GND ADC_VDD AHS1 / V0 AVS1 / VCLK 3 R1.8DVCC AHS1 AVS1 30 31 32 33 34 35 36 37 38 39 40 50 51 AHS1 AVS1 B1B1+ G1G1+ SOG1 R1R1+ 2 DGND BJT_B B1B1+ G1G1+ SOG1 R1R1+ XI SCLK/PWM0 0.1uF 1 RESET_OUT C421 0.1uF U403 XO PWM1/DDCSCL/SCSB C420 RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+ PWM0/SDIO[3] + RXE0RXE0+ RXE1RXE1+ RXE2RXE2+ RXECRXEC+ RXE3RXE3+ 16 10uF/16V 94 93 92 91 90 89 88 87 86 85 DDCSDA1 C418 0.1uF AG3N / TXO0AG3P / TXO0+ ACLKN / TXO1ACLKP / TXO1+ AB1N / TXO2AB1P / TXO2+ AB2N / TXOCAB2P / TXOC+ AB3N / TXO3AB3P / TXO3+ DDCSCL1 C419 RTD2523B ( RSDS & LVDS ) 33VRST_REF 1.8DVCC AVS0 AHS0 ADC_VDD ADC_GND B0+ B0SOG0 G0+ G0R0+ R0- DEL R418 106 105 104 103 102 101 100 99 98 97 ADC_VDD 19 20 21 22 23 24 25 26 27 28 29 R1.8AVCC 0 1/16W MCU_RST ADC_GND R425 R426 R412 RTD_SCLK RTD_SCSB RTD_SD3/SDI SDIO2 SDIO1 SDIO0 15 0.1uF AR1N AR1P AR2N AR2P AR3N AR3P AG1N AG1P AG2N AG2P 33VRST_REF RST_OUT 14 C417 0.1uF R423 R424 TMDS_TST / PWM0 / TCON2 REXT TMDS_VDD RX2P RX2N TMDS_GND RX1P RX1N TMDS_VDD RX0P RX0N TMDS_GND RXCP RXCN 124 123 122 121 120 119 118 115 114 113 112 111 110 109 13 RXCP RXCN C416 FB405 600 OHM RX0P RX0N R419 R422 5 6 7 0 1/16W 8 0 1/16W 9 10 0 1/16W 11 0 1/16W 12 13 0 1/16W 14 0 1/16W 15 16 0 1/16W 17 0 1/16W 18 PWM1 / TCON0 / COUT PWM2 / TCON1/TCON7 BJT_B BB3P/BBLU7 BB3N/BBLU6 BB2P/BBLU5 BB2N/BBLU4 BB1P/BBLU3 BB1N/BBLU2 BCLKP/BGRN7 BCLKN/BGRN6 BG3P/BGRN5 BG3N/BGRN4 1K 1/16W TMDS_VCC +3.3V 1.8DVCC 33VRST_REF RESET_OUT TCON9 / PWM0 DDCSCL2 / VCLK / TCON4 DDCSDA2 / V7 / TCON6 SCLK / V6 / TCON3 SCSB / V5 / TCON7 SDIO[3] / V4 / TCON9 SDIO[2] / V3 / TCON5 SDIO[1] / V2 / TCON8 SDIO[0] / V1 / TCON10 V0 / TCON2/PWM1 TCON13 / COUT 33VPNLOUT 48 49 58 61 62 63 64 65 66 67 68 69 70 RX1P RX1N R421 R416 R417 SDIO[0] / TCON13 SDIO[1] / TCON7 SDIO[2] / TCON11 SDIO[3] / TCON0 SCSB / TCON12 SCLK / TCON3 R420 NC RX2P RX2N DDCSCL1 / TCON4 DDCSDA1 / TCON9 4.7K 1/16W FB404 600 OHM XO XI DPLL_VDD DPLL_GND APLL_GND APLL_VDD PLL_TEST1 / TCON0 / TCON3 PLL_TEST2 / TCON1 / TCON12 TMDS_VCC R414 NC R415 +3.3V 127 128 125 126 1 2 3 4 52 53 54 55 56 57 R413 NC 4.7K 1/16W R1.8AVCC R411 PVCC PVCC PVCC PVCC PVCC XO XI R410 4.7K 1/16W R409 30K 1/16W 4.7K 1/16W U401 VCCK VCCK 0.1uF 46 117 C415 0.1uF GNDK GNDK C414 Voltage to 2.2V (if use 5V the R 25K and 20K; 3.3Vuse 15K and 30K ) R407 15K 1/16W DGND DGND +3.3V R430 1.8DVCC NC +3.3V VOLUME BRIGHTNESS R431 R432 R433 R434 0 1/16W Q401 0 1/16W Q402 PMBS3906 0 1/16W Q403 PMBS3906 0 1/16W 3 2 NC/2SB1188 1.8DVCC 1 3.3V_Vd Title Size Date: - 78 – ViewSonic Corporation Document Number 715G1675-B SCALER Sheet Thursday, July 28, 2005 Rev T1 1 of 4 11.4 INPUT FB406 30 OHM FB409 0 OHM R435 100 1/16W VGA_B C422 0.047uF B1+ R436 75 1/16W CN402 C423 10pF R437 100 1/16W VGA_B- C424 0.047uF R438 100 1/16W B1- B1- 30 OHM FB410 0 OHM R439 100 1/16W VGA_G R443 75 1/16W G1+ FB411 0 OHM VGA_R R447 75 1/16W C430 10pF VGA_R- DVI_POWER DVI_DET 1M 1/16W R445 100 1/16W C428 0.047uF R446 100 1/16W C429 0.047uF R448 100 1/16W C431 0.047uF G1- R441 2K 1/16W DVI_DET RX0N RX0P D403 R1- RX0N RX0P R444 3.3K 1/16W RXCP RXCP RXCN RXCN G1UDZS5.6B R1+ RX1N RX1P RX1N RX1P BUS_POWER R440 G1+ C427 10pF VGA_GFB408 30 OHM C426 0.047uF 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 DDC2_SCL DDC2_SDA C425 0.047uF SOG1 FB407 RX2N RX2P RX2N RX2P R1+ C1 C2 C3 C4 C5 DATA2DATA2+ DATA2/4 SHLD DATA4DATA4+ DDC CLK DDC DATA A-VSHNC DATA1DATA1+ DATA1/3 SHLD DATA3DATA3+ +5v GND H-PLUG-DET DATA0DATA0+ DATA0/5 SHLD DATA5DATA5+ CLK-SHLD CLK+ CLKA-RED A-GREEN A-BLUE A-HSY NC A-GND R1DVI-CON SHIELD connect to Chassis, Then Chassis connect to DGND. VSIN HSIN VSIN R449 R452 2K 1/16W D401 0 1/16W R450 R451 R453 2K 1/16W C432 22pF D402 UDZS5.6B AHS1 AVS1 100 1/16W 100 1/16W AHS1 AVS1 C433 10pF CN403 UDZS5.6B DEL ZD1, ADD D28,D29 2005/3/28 DDC_SCL VSIN DDC_SDA CN401 DDC_SCL DDCSCL 15 VSIN VSIN 14 HSIN HSIN 13 5 10 4 9 3 8 2 7 1 6 DDC_SDA DDCSDA 12 RXD RXD RXD11 CONNECT TXD VGA5V B BAGND G GAGND R RAGND RXE0RXE1RXE2RXECRXE3RXO0RXO1RXO2RXOCRXO3- RXE0RXE1RXE2RXECRXE3RXO0RXO1RXO2RXOCRXO3- CONNECT TXD DDC_VDD VGA_B VGA_BVGA_G VGA_GVGA_R VGA_R- 1 3 5 7 9 11 13 15 17 19 21 23 2 4 6 8 10 12 14 16 18 20 22 24 RXE0+ RXE1+ RXE2+ RXEC+ RXE3+ RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+ RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ PANEL_POWER TXD VGA5V CONN panel interface R4012 0 1/16W DB15 ESD solution C434 NC 1 NC NC C435 NC 3 VGA_G DGND NC 3 3 D410 C459 NC D411 BAV99 NC +3.3V BAV99 C460 1 BAV99 1 C458 2 D409 BAV99 1 1 2 NC C457 2 D408 BAV99 1 C456 2 D407 BAV99 RX2N RX2P 3 3 3 RX2N RX2P NC +3.3V D415 UDZS5.6B DDC_VDD DGND D416 UDZS5.6B DDC_SCL DDC_SCL DGND C436 NC +3.3V RX1N RX1P D413 BAV99 1 2 C455 NC +3.3V 2 D406 BAV99 1 C454 2 D405 BAV99 1 C453 2 VGA_R RX1N RX1P 2 D404 3 RXCN RXCP 3 3 D412 BAV99 1 2 RXCN RXCP 2 +3.3V RX0N RX0P 3 RX0N RX0P ESD solution +3.3V D414 BAV99 3 VGA_B 1 DGND DGND D417 UDZS5.6B CONNECT D419 UDZS5.6B D421 UDZS5.6B DGND TXD DGND RXD DGND D418 UDZS5.6B D420 UDZS5.6B D422 UDZS5.6B DDC_SDA DDC_SDA DDC2_SCL Title DDC2_SDA Size ESD solution Date: - 79 – ViewSonic Corporation Document Number 715L1675-B INPUTSheet Thursday, July 28, 2005 Rev T1 2 of 4 Inverter L201 C206 0.1uF/25V C208 0.1uF/25V C209 0.001uF /50V Q204 R208 2.4KΩ 1/10W C212 0.0047uF/50V C213 0.1uF/25V R209 47KΩ 1/10W D204 RB050L-40 D201 RB050L-40 PMBS3904 8 3 R207 C211 0.33uF/250V 68KΩ 1/10W Q205 PMBS3906 1 R210 470Ω 1/10W R211 6 10 8 Vfb SDP 10 9 OLP COMP C216 0.22uF/25V R213 1.5KΩ 1/10W R215 150KΩ 1/10W D205 MLL4148 D206 MLL4148 R216 1.5KΩ 1/10W C217 1uF/25V 8 3 R214 1KΩ 1/10W 6 10 R219 56KΩ 1/10W DIM R220 33KΩ 1/10W R221 30KΩ 1/10W D207 MLL4148 Q208 PMBS3904 1.POWER OUTPUT 12V & 5 V Size Document Number Custom Rev PWPC1742CPV2P(715G1686 C) Monday , August 29, 2005 Sheet 1 B of is power GND R228 330KΩ 1/8W is signal GND 1 - 80 – ViewSonic Corporation CN202 CONN 1 2 TP3 HVO TP4 HVL CN203 CONN PT202 O O 11 1 2 C214 10pF/3KV O C215 10pF/3KV O CN204 CONN 1 2 R217 1KΩ 1/10W D212 MLL4148 R222 1KΩ 1/10W D214 MLL4148 AOC (Top Victory) Electronics Co., Ltd. Date: D208 MLL4148 D209 MLL4148 GND Title C210 10pF/3KV O D210 MLL4148 D211 MLL4148 C219 0.047uF/50V C220 0.01uF/25V C205 10pF/3KV O 12 9 INVERTER X'FMR R229 NC C218 1uF/25V R218 68KΩ 1/10W 1 2 22KΩ 1/10W R212 51KΩ 1/10W C225 NC 11 12 9 INVERTER X'FMR 1 Q206 Q207 KTC5103L-Y -U/P KTC5103L-Y -U/P 7 6 Css 11 OSC RCt 5 Vms 12 Vcc 13 Vref 4 3 Vds 14 OUT Vcc1 GND 1 2 IC201 FM7547 O MLL4148 1 R230 NC O 1 1 CN201 CONN PT201 1 D203 TP2 HVO 1 C207 0.22uF/25V MLL4148 R204 R205 1.8KΩ 1/4W1.8KΩ 1/4W 2 ON/OFF D202 R206 220Ω 1/10W 2 470uF/25V R201 2.4KΩ 1/10W C203 0.1uF/25V R202 R203 1.8KΩ 1/4W1.8KΩ 1/4W 3 C204 0.1uF/25V 3 Q203 DTC144WKA + C202 TP1 HVO 47 uH Q201 AOU401L 1 C201 0.1uF/25V 1 Q202 DTA144WKA 2 2 3 3 +12V 1 11.5 D216 MLL4148 D213 MLL4148 R223 1KΩ 1/10W D215 MLL4148 R226 10KΩ 1/10W C221 0.0022uF/50V R224 10KΩ 1/10W D217 MLL4148 C222 0.0022uF/50V R227 10KΩ 1/10W C223 0.0022uF/50V R225 10KΩ 1/10W C224 0.0022uF/50V A-D Power 4 11.6 + DB901 KBP206G C920 0.001uF/500V 3 3 - R903 430KΩ 1/8W L902 + R906 510KΩ 1/8W C904 1500pF/1KV C903 100uF/450V C902 0.001uF/250V 4 R904 430KΩ 1/8W D901 UF4003 2 C906 22uF/50V R910 2.2Ω 1/8W 2 7 1O F902 0Ω 1/8W + C924 1000uF/25V + C925 470uF/25V ZD920 PTZ9.1B L D921 31DQ06 +5V + C923 1000uF/16V + C926 470uF/16V 9 R908 510KΩ 1/8W 7 R913 1KΩ 1/10W C907 220PF/25V R914 R902 330KΩ 1/8W R922 220Ω 1/4W R916 R915 0.33Ω 2W 10KΩ 1/10W D922 MLL4148 2 C934 0.022uF/25V SW901 R918 75KΩ 1/10W IC921 KIA431A-AT/P 3 R919 100KΩ 1/10W D923 MLL4148 R926 33KΩ 1/10W 1% 1 2 3 4 5 6 7 8 9 10 C929 NC C930 0.1uF /50V R927 1KΩ 1/10W DIM +12V C927 0.1uF /50V +5V CONN C931 0.1uF/50V R929 2.4KΩ 1/10W 1% 3 SW ON/OFF R928 3.9KΩ 1/10W 1 2 C908 0.1uF/25V R924 3.6KΩ 1/10W 1% R925 1KΩ 1/10W 2 3 IC903 KIA431A-AT/P R923 NC CN903 IC902 PC123FY2 4P R917 100Ω 1/8W F901 FUSE ZD922 RLZ5.1B ZD921 RLZ13B NR901 NTCR t NC C932 0.0022uF/250V 1 10KΩ 1/10W 1 R900 330KΩ 1/8W Q900 2SK2645-54MR 2 6 1 5 R912 10Ω 1/4W 1 R911 100KΩ 1/10W 8 2 C900 0.47uF/250V R901 330KΩ 1/8W 4 LD7552 2 IC901 LD7552 3 1 L 4 + R905 430KΩ 1/8W 8 4 3 C905 0.1uF/50V R921 C921 47Ω 1/2W 0.001uF/500V + C922 1000uF/25V L922 6 L +12V 11 O 10 D900 BA159G R907 510KΩ 1/8W C901 0.001uF/250V L901 R909 100KΩ 2W TY PE F 1 1 L VAR901 L921 2 12 1 3 2 4 O D920 FME-210B 2 1 T901 1 2 R920 47Ω 1/2W 2 1 AOC (Top Victory) Electronics Co., Ltd. CN901 SOCKET Title - 81 – ViewSonic Corporation 1.POWER OUTPUT 12V & 5 V Size B Document Number Date: Monday , August 29, 2005 Rev PWPC1742CPV2P(715G1686 C) Sheet 1 B of 1 11.7 Audio OUT_L +12V 12V CN202 pin header2*7 2mm f emale MUTE 13 11 9 7 5 3 1 CN204 3 2 1 14 12 10 8 6 4 2 + + C202 680uF/25V C201 680uF/25V C203 0.1uF 6 11 200 12 C211 100pF GND R211 20K 1/16W R210 20K 1/16W GND C212 100pF + C209 1.0uF + C210 1.0uF C213 0.1uF GND 15 + VS OUTL INR OUTR VOLUME SVR STBY VAROUT_R MUTE VAROUT_L 470uF/16V C207 10 7 5 R207 Size A Date: R208 + C208 GND - 82 – 470uF/16V 14 + 16 INL Title ViewSonic Corporation C205 17 1K R212 R203 18K 1/16W PHONEJACK GND 1K C206 0.47uF/25V9 VS 8 C204 0.47uF/25V 4 18K 1/16W NC R201 GND GND GND GND GND GND GND 1 5 4 3 2 U201 TDA7496L 1 2 3 13 18 19 20 VOLUME GND CN201 STANDBY OUT_R GND NC 470uF/16V GND Audio Document Number <Doc> Saturday , October 11, 2003 Rev <Rev Code> Sheet 1 of 1 11.8 Key Pad FB001 1 120 OHM 2 FB002 1 2 120 OHM DP2 LED SW001 SW002 SW003 SW004 SW005 SW006 SW SW SW SW SW SW CN006 LED ORANGE LED GREEN LCD ON/OFF KEY 2 KEY 1 KEY DOWN KEY UP MUTE SPKR_R+ SPKR_L+ GND LED GREEN KEY 2 KEY UP LCD ON/OFF GND SPKR_L+ 1 3 5 7 9 11 2 4 6 8 10 12 LED ORANGE KEY 1 KEY DOWN GND MUTE SPKR_R+ CONN CN003 GND 1 2 GND CONN CN002 GND 1 2 GND CONN AOC (Top Victory) Electronics Co., Ltd. Title KEY PAD (For Viewsonic VA713) - 83 – ViewSonic Corporation Size A Document Number Date: Saturday , September 10, 2005 Rev B CONTROL KEY PAD (Switch) Sheet 1 of 1 12. PCB Layout Diagram 12.1 MAIN BOARD PCB TOP VIEW - 84 – ViewSonic Corporation - 85 – ViewSonic Corporation 12.2 MAIN BOARD PCB BUTTON VIEW - 86 – ViewSonic Corporation 12..3 KEYBOARD TOP VIEW 12.4 KEYBOARD BUTTON VIEW - 87 – ViewSonic Corporation 12.5 POWER PCB TOP VIEW - 88 – ViewSonic Corporation 12.6 POWER PCB BUTTON VIEW - 89 – ViewSonic Corporation 12.6 AUDIO PCB TOP VIEW & BUTTON VIEW - 90 – ViewSonic Corporation * Reader’s Response* Dear Readers: Thank you in advance for you feedback on our Service Manual, which allows continuous improvement of our products. We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic Corporation. Assessment A. What do you think about the content after reading VA712b-2 Service Manual? Unit 1. Precautions And Safety Notice 2. Specification 3. Front Panel Control and Indicators 4. Circuit Description 5. Adjust Procedure 6. Troubleshooting Flow Chart 7. Recommended Spare Parts List 8. Exploded Diagram And Spare Parts List 9. Block Diagram 10. Schematic Diagram 11. PCB Layout Diagram Excellent Good Fair Bad Good Fair Bad B. Are you satisfied with the VA712b-2 Service Manual? Item 1. Service Manual Content 2. Service Manual Layout 3. The form and listing Excellent C. Do you have any opinion and suggestion about this Service Manual? Reader’s Basic Data: Name: Title: Company: Add: Tel: Fax : E-Mail: After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestion to the Director, Quality System & Process ([email protected]) - 91 – ViewSonic Corporation