Download SERVICE MANUAL

TA-AV581
SERVICE MANUAL
AEP Model
E Model
Australian Model
• This set is the amplifier
section in SEN-T581.
Manufactured under license from Dolby Laboratories
Licensing Corporation.
“DOLBY” and the double-D symbol a and “Pro
Logic” are trademarks of Dolby Laboratories
Licensing Corporation.
SPECIFICATIONS
Amplifier section
European models:
(FRONT)
DIN power output
100 W + 100 W (at rear/center/
woofer off at 1 kHz, 8 Ω)
Continuous RMS power output
120 W + 120 W (at rear/center/
woofer off at 1 kHz, 10%
T.H.D., 8 Ω)
80 W/ch (at SURROUND ON
at 1 kHz, 10% T.H.D., 8 Ω)
(REAR)
50 W (at front/center/woofer
off at 1 kHz, 8 Ω)
(CENTER)
50 W (at front/rear/woofer off
at 1 kHz, 8 Ω)
(WOOFER)
80 W (at front/rear/center off
at 40 Hz, 4 Ω)
Other models:
Peak music power output
1900 W (total)
(FRONT)
Continuous RMS power output
100 W + 100 W (at rear/center/
woofer off at 1 kHz, 10%
T.H.D., 8 Ω)
(REAR)
50 W (at front/center/woofer
off at 1 kHz, 8 Ω)
(CENTER)
50 W (at front/rear/woofer off
at 1 kHz, 8Ω)
(WOOFER)
80 W (at front/rear/center off at
40 Hz, 4 Ω)
Inputs
PHONO (phono jacks):
sensitivity 2.5 mV,
impedance 50 kΩ
CD (phono jacks):
sensitivity 400 mV,
impedance 50 kΩ
TUNER, TAPE, VIDEO1,2 (phono jacks):
sensitivity 250 mV,
impedance 50 kΩ
General
Power requirements
European, Australian and Singaporean models:
230 V AC, 50/60 Hz
Other models: 110-120 V AC or
220-240 V AC, 50/60 Hz
(adjustable with the voltage
selector)
Power consumption
180 W
AC outlets
3 switched, total 100 W max.
Dimensions (w/h/d)
Approx. 430 × 160 × 355 mm
Mass
Approx. 8.5 kg
Supplied accessories
Remote RM-U581 (1)
Sony SUM-3 (NS) batteries (2)
Design and specifications are subject to change
without notice.
Outputs
TAPE REC OUT, VIDEO 1 (phono jacks):
voltage 250 mV,
impedance 1 kΩ
PHONES (stereo phone jack):
accepts low and high
impedance headphones
TONE
± 10dB at 100 Hz and 10 kHz
INTEGRATED AV AMPLIFIER
MICROFILM
SECTION 1
TEST MODE
TABLE OF CONTENTS
1.
TEST MODE ··································································· 2
2.
GENERAL ······································································· 3
3.
DIAGRAMS
3-1. Circuit Boads Location ························································ 4
3-2. Printed Wiring Boards – Display Section – ························· 5
3-3. Schematic Diagram – Display Section – ····························· 7
3-4. Printed Wiring Boards – Power Section – ··························· 9
3-5. Schematic Diagram – Power Section – ····························· 11
3-6. Printed Wiring Board – Main Section – ···························· 13
3-7. Schematic Diagram – Main Section (1/2) – ······················ 15
3-8. Schematic Diagram – Main Section (2/2) – ······················ 17
3-9. IC Pin Function Description ·············································· 19
3-10. IC Block Diagrams ···························································· 21
4.
[Fluorescent Indicator Tube, LED All Lit, and Key Check Mode]
1. When the plug is inserted into the outlet while pressing the
3 CLASSIC button, the fluorescent indicator tube and LED
will light up completely.
2. The mode changes as follows each time the 3 CLASSIC button
and WOOFER ON/OFF button are pressed together after 1.
Sequence of Service Modes
Fluorescent Indicator
Tube and LED Check Mode*1
• Press the 3 CLASSIC button and
WOOFER ON/OFF button at the same time.
AMP check mode *2
• Press the 3 CLASSIC button and
WOOFER ON/OFF button at the same time.
EXPLODED VIEWS
KEY check mode *3
• Press the 3 CLASSIC button and
WOOFER ON/OFF button at the same time.
4-1. Front Panel Section ···························································· 23
4-2. Chassis Section ·································································· 24
5.
ELECTRICAL PARTS LIST ···································· 25
*1 For checking if the fluorescent indicator tube and LED are lit
completely
*2 When the AMP check mode is set, “AMP” is displayed on the
fluorescent indicator tube. As this mode is not used for servicing,
perform step 2 to enter the KEY check mode.
*3 When the KEY check mode is set, “KEY 0”is displayed on the
fluorescent indicator tube. Each press of the button is counted.
(This excludes the | / u button)
When all buttons are pressed, the AMP check mode is set.
Buttons pressed once will not be counted when pressed again.
3. To exit the test mode, press the | / u button
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH
MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
—2—
SECTION 2
GENERAL
LOCATION AND FUNCTION OF CONTROLS
[FRONT PANEL]
!º TUNER button
!¡ CD button
!™ TAPE button
!£ VIDEO 2 button
!¢ VIDEO 1 button
!∞ SOUND FIELD buttons
!§ CENTER MODE button
!¶ PHONES jack
1 POWER switch (I/u)
2 DOLBY PRO LOGIC indicator
3 SURROUND MODE buttons
4 +, – buttons
5 CONTROL MODE buttons
6 SUPER WOOFER indicator
7 MASTER VOLUME control
8 WOOFER ON/OFF button
9 PHONO button
[REAR PANEL]
Photo : AEP, Singapore, Australian Model
1 REAR SPEAKERS
2 AC OUTLET
(AEP, Singapore, Australian Model)
3 AC power cord
4 WOOFER SPEAKER
5 CENTER SPEAKER
6 FRONT SPEAKERS
7 VIDEO 1
8 VIDEO 2
9 TAPE
!º CD
!¡ TUNER
!™ PHONO
—3—
SECTION 3
DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION
TRANS 1 board
TRANS 2 board
OUTLET board (AEP, SP, AUS Model)
POWER board
REAR SP board
SW board
HP board
DISPLAY board
MAIN board
VOL board
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this necessary note is printed in each
block.)
For Schematic Diagrams.
Note:
For Printed Wiring Boards.
Note:
• All capacitors are in µF unless otherwise noted. pF:
µµF 50 WV or less are not indicated except for
electrolytics and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
•
¢
: internal component.
• 2 : nonflammable resistor.
• 1 : fusible resistor.
• C : panel designation.
• X : parts extracted from the component side.
•
®
: Through hole.
•
¢
: internal component.
• b : Pattern from the side which enables seeing.
Note : The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
•
•
•
•
•
•
•
•
•
U : B+ Line.
V : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
No mark : FM
Voltages are taken with a VOM (Input impedance
10MΩ).
Voltage variations may be noted due to normal
production tolerances.
Waveforms are taken with a oscilloscope.
Circled numbers refer to waveforms.
Signal path.
F
: FM
Abbreviation
AUS : Australian model.
SP
: Singapore model.
• Waveform
• DISPLAY SECTION
1 IC401 #∞ (X2)
5MHz
5.8Vp-p
• MAIN SECTION
2 IC300 $§ (OSC)
8.0MHz
4.0Vp-p
TA-AV581
3-2. PRINTED WIRING BOARDS — DISPLAY SECTION —
1
3
A
2
• See page 4 for Circuit Boards Location.
4
5
6
7
8
9
10
11
12
D (Page 10)
(Page 13)
13
14
DISPLAY BOARD
A
FL401 FLUORESCENT INDICATOR TUBE
1
4
30
33
1
3
(STANDBY)
CN402
B
1 80
(SIMULATED)
(HALL)
(WOOFER) (REAR) (CENTER) (TONE)
(DOLBY PRO LOGIC)
6
65
64
24
E
1
(DOLBY)
(SUPER WOOFER)
IC401
CN401
E
E
25
E
E
C
40 41
4
1
CENTER
MODE
D
WOOFER
ON/OFF
WOOFER
5 GAME
REAR
CENTER
TONE
SIMULATED
4 MOVIE
HALL
DOLBY
3 CLASSIC
2 POPS
E
1 LOCK
CN405
1
PHONO
TUNER
CD
TAPE
VIDEO 2
11
VIDEO 1
1-669-717-
F
VOL BOARD
HP BOARD
CN406
SW BOARD
1
G
4
6
1
4
S401
H
1-670-20611
1-669-721-
16
J401
PHONES
1
MASTER
VOLUME
11
(11)
11
(11)
1-669-722-
• Semiconductor Location
Ref. No. Location
Ref. No. Location
D401
D402
D403
D404
D406
D407
D408
D409
D410
D411
D412
D413
D414
D415
D416
D417
D418
D419
B-9
B-9
B-9
C-3
IC401
IC402
IC403
C-6
C-12
B-10
Q401
Q402
Q403
Q404
C-4
C-10
C-9
C-3
B-5
B-11
B-11
C-12
C-4
B-5
B-5
B-4
B-4
B-3
B-2
B-12
B-11
B-10
—5—
4
—6—
(11)
(11)
TA-AV581
3-3. SCHEMATIC DIAGRAM — DISPLAY SECTION—
—7—
• See page 4 for Waveform.
• See page 19 for IC Pin Function Description.
—8—
TA-AV581
3-4. PRINTED WIRING BOARDS — POWER SECTION —
1
• Semiconductor
Location
Ref. No. Location
D951
D952
D953
D954
D955
D956
F-8
F-8
F-7
F-7
F-10
E-6
Q901
Q902
E-7
E-6
• See page 4 for Circuit Boards Location.
3
2
4
5
6
7
8
9
10
11
12
13
REAR SP BOARD
R
A
L
REAR
SPEAKERS
POWER BOARD
TRANS 1 BOARD
AC
IN
AC OUTLET
CN906
11
B
1-669-716-
E Model
1
CN903
(11)
E Model
OUTLET BOARD
AEP,SP,AUS Model
S902
VOLTAGE
SELECTOR
1
E Model
CN913
1
2
3
2
1
1
2
F903
C
1-669-719-
3
E Model
AEP,SP,AUS Model
11
1
2
(11)
CN103
1
CNJ901
AEP,SP,AUS Model
4
T901
POWER
TRANSFORMER
D
E Model
C
11
(Page 14)
1-669-723E
E
E
AC OUTLET
T902
POWER
TRANSFORMER
AEP,SP,AUS Model
D
CN907
F
1-669-718-
11
(11)
CN902
1
G
12
11
1-669-720-
(11)
TRANS 2 BOARD
B
16
(Page 13)
H
—9—
(11)
— 10 —
(Page 6)
TA-AV581
3-5. SCHEMATIC DIAGRAM — POWER SECTION—
— 11 —
— 12 —
TA-AV581
• See page 4 for Circuit Boards Location.
3-6. PRINTED WIRING BOARD — MAIN SECTION —
• Semiconductor
Location
1
Q121
Q131
Q221
Q231
Q331
Q332
Q381
Q382
Q502
Q503
Q551
Q552
Q553
Q554
Q560
Q570
Q610
Q620
Q670
Q701
Q702
Q703
Q704
Q710
Q711
Q720
Q721
Q722
Q723
Q740
Q751
Q752
Q753
Q754
Q770
Q801
Q803
C-4
B-2
C-3
B-2
D-9
D-8
E-9
E-8
D-4
D-4
I-8
J-8
J-7
J-8
G-7
I-7
G-10
I-9
H-10
I-2
J-3
J-2
J-3
G-3
H-2
I-4
G-3
H-3
G-2
H-7
I-5
J-5
J-5
J-6
I-5
F-1
G-5
7
8
9
10
11
12
13
A
1
1
B
80
65
E
E
R
L
8
24
PHONO
IN
64
R
25
L
E
E
40
TUNER
IN
41
R
C
16
L
3
R
8
5
8
1
A
L
4
R
4
E
5
L
E
8
TAPE
IN
E
E
1
E
R
4
L
E
VIDEO 2
AUDIO IN
R
L
1
12
B
F
TAPE
REC OUT
1
E
1
3
(Page 5)
CD
IN
1
15
1
5
D
30
L
(Page 9)
E
VIDEO 1
AUDIO OUT
R
RY801
E
E
C
VIDEO 1
AUDIO IN
(Page 9)
E
G
E
E
E
1
E
4
E
H
1
E
1
2
R
9
FRONT
SPEAKERS
E
14
15
L
TM701
C-10
B-11
B-7
B-4
D-7
D-5
D-4
H-8
J-10
H-5
C-3
D-3
6
IC102
IC101
IC102
IC300
IC301
IC303
IC501
IC502
IC551
IC601
IC701
IC801
IC802
5
CN501
C-4
C-4
D-5
G-8
H-9
G-10
H-9
G-3
H-2
H-3
H-3
H-2
H-2
E-4
H-2
E-4
F-1
F-5
E-8
G-4
G-3
F-3
F-3
F-3
4
MAIN BOARD
Ref. No. Location
D521
D522
D523
D560
D601
D610
D651
D710
D711
D721
D722
D723
D724
D725
D726
D727
D801
D802
D803
D818
D820
D821
D822
D823
3
2
E
E
E
E
E
E
CENTER
SPEAKER
I
WOOFER
SPEAKER
E
1
E
16
E
E
10
IC601
J
— 13 —
— 14 —
18
11
1-669-715-
(11)
TA-AV581
3-7. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) —
—15 —
• See page 22 for IC Block Diagrams.
— 16 —
TA-AV581
3-8. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) —
— 17 —
• See page 4 for Waveform.
• See page 21,22 for IC Block Diagrams.
— 18 —
3-9. IC PIN FUNCTION DESCRIPTION
• IC401 µPD78042FGF-089-3B9 (DISPLAY BOARD)
Pin No.
Pin Name
I/O
1
DIG 2
O
Fluorescent tube segment signal output
Function
2
DIG 3
O
Fluorescent tube segment signal output
3
DIG 4
O
Fluorescent tube segment signal output
4
DIG 5
O
Fluorescent tube segment signal output
5
DIG 6
O
Fluorescent tube segment signal output
6
DIG 7
O
Fluorescent tube segment signal output
7
DIG 8
O
Fluorescent tube segment signal output
8
+5 V
—
Power supply +5 V
9
POWER-RY
O
Power-relay ON/OFF drive signal output H when power is on
10
BRIDGE. RY
O
Bridge relay drive signal output H when surround is off
11
WOOFER RELAY
O
Woofer relay drive signal output H when super woofer is on
12
SURR. RY
O
Surround speaker relay ON/OFF drive signal output H when surrounded speaker is on
13
FRONT. RY
O
Front speaker relay ON/OFF drive signal output H when power is on
14
HP. RY
O
Headphone relay ON/OFF drive signal output H when headphone plug in is detected
15
LV1041. CE1
O
Chip enable signal output. Transfer center and rear speaker data at low
16
LV1041. CE2
O
Chip enable signal output. Transfer Dolby and surround data at low
17
RESET
I
Reset signal input
18
P. CHECK
I
Power check input (Connected to ground)
19
HP. SW
I
PHONES jack in detection pin
20
AVSS
—
Ground
21
IC. MUTE
O
Mute control output Low for IC-muting
22
LC7822. CE
O
Chip enable signal output Transfer data at 4 bit low and 8 bit high
23
LC75373. CE
O
Chip enable signal output Transfer IC address at low, data at high
24
CLOCK
O
Serial clock output
25
DATA
O
Serial data output
26
VERSION
I
Destination discrimination pin (Connected to reference voltage)
27
KEY. 2
I
Key matrix input 2
28
KEY. 1
I
Key matrix input 1
29
AVDD
—
Power supply +5 V
30
AV. REF
—
Power supply +5 V
31
BACKUP
I
32
XT 2
—
Not used
33
VSS
—
Ground
34
X1
—
X’tal (5 MHz)
35
X2
—
X’tal (5 MHz)
36
TONE LED
O
37
CENTER LED
O
CENTER LED drive signal output ACTIVE LOW when Center level adjusting mode
38
REAR LED
O
REAR LED drive signal output ACTIVE LOW when rear level mode
39
WOOFER LED
O
WOOFER LED drive signal output ACTIVE LOW when woofer level adjusting mode
40
S.W. LED
O
S.W. LED drive signal output ACTIVE LOW when super woofer is on
41
DOLBY LED
O
42
HALL LED
O
43
SIMULATED LED
O
44
VOL. B
I
Volume encoder signal input
45
VOL. A
I
Volume encoder signal input
46
PROTECT
I
Protect signal input
47
SIRCS
I
SIRCS signal input
48
VSS
—
Ground
49
GND
—
Ground
50
GND
—
Ground
Backup signal input, monitoring the microprocessor voltage at all times
TONE LED drive signal output. ACTIVE LOW when BASS/TREBLE level
adjusting mode
DOLBY LED drive signal output ACTIVE LOW when surround Dolby or sound
field mode is selected
HALL LED drive signal output ACTIVE LOW when surround hall or surround field
classic is selected
SIMULATED LED drive signal output ACTIVE LOW when surround SIMU or
surround field game is selected
— 19 —
Pin No.
Pin Name
I/O
51
GND
—
Ground
Function
52
+5 V
—
Power supply +5 V
53
10DB. ATT
O
10 dB ATT. switch output H when volume ATT. is used
54
FUNC. MUTE
O
Line mute control output H for muting
55
S.W. PHASE
O
Super Woofer phase switch output L for normal, H for reverse
56
STANDBY LED
O
STANDBY LED drive signal output
57
NC
—
Not connected
58
NC
—
Not connected
59
S 18
O
Fluorescent tube segment signal output
60
S 17
O
Fluorescent tube segment signal output
61
S 16
O
Fluorescent tube segment signal output
62
S 15
O
Fluorescent tube segment signal output
63
S 14
O
Fluorescent tube segment signal output
64
S 13
O
Fluorescent tube segment signal output
65
S 12
O
Fluorescent tube segment signal output
66
S 11
O
Fluorescent tube segment signal output
67
S 10
O
Fluorescent tube segment signal output
68
S9
O
Fluorescent tube segment signal output
69
S8
O
Fluorescent tube segment signal output
70
S7
O
Fluorescent tube segment signal output
71
VLOAD
—
Power supply –28 V power supply for fluorescent tube segment
72
S6
O
Fluorescent tube segment signal output
73
S5
O
Fluorescent tube segment signal output
74
S4
O
Fluorescent tube segment signal output
75
S3
O
Fluorescent tube segment signal output
76
S2
O
Fluorescent tube segment signal output
77
S1
O
Fluorescent tube segment signal output
78
NC
—
Not connected
79
NC
—
Not connected
80
DIGI
O
Fluorescent tube segment signal output
— 20 —
3-10. IC BLOCK DIAGRAMS
IC300
LV1041M (MAIN BOARD)
L-R RECT
DC CUT2
L+R RECT
VCS TH
VCS 1
VCS 2
VLR 2
VLR 1
VLR TH
L RECT
DC CUT4
R RECT
DC CUT3
L BPF3
77
76
75
74
73
72
71
70
69
68
67
66
65
R DET3
DC CUT1
80 79 78
R BPF2
1
R BPF1
2
RECT
BPF
LOGIC
FF
RECT
LOGIC
FF
LOGIC
VCA
S DC OUT
C DC OUT
R DC OUT
L DC OUT
64 L BPF2
RECT
RECT
BPF
63 L BPF1
R
62 RT IN
L
61 LT IN
LOGIC
VCA
VCA
VCA
P
VOL
B
3
4
5
VCA
VCA
VCA
VCA
P
6
VOL
B
CH
CONTROL
60 DC CUT
V REF
VCC
7
C OUT
9
BPF
CONTROL
S
MODE
V REF
8
59
58
57
56
C MODE
STRIM
C
NOISE
FILTER
S OUT 10
S
OSC
P
R OUT 11
R
R
P
NOISE
GEN
B
C MODE
GND
NS BPF1
NS BPF2
55 OSC
IEV
B
P
L
L OUT 12
12
L
P
B
B
54 CLK
STRIM
GND 13
B NR
P
B
P
L IN 14
D
L
B
P
C
53 DATA
P
IN
FILTER
S
B
B
DATA
DECODER
OUT
FILTER
52 ENABLE
B
R
B
P
P
R IN 15
P
DC
CUT
VOL/
MUTE
51 DATA
B
S IN 16
50 CLK
49 ENABLE2
SRAM
48 VSS
S
P
PCM
CONTROL
S
DELAY OUT 17
P
B
P
B
B
47 OSC
46 OSC
C VOL IN 18
S
R
L
PCM
45 VDD
VDD
DET 19
IREF 20
20
44 A/D
R
R OUT 21
L
L NF 23
43 NS
NF
SW
MASTER VOL
S
C
MASTER
VOL
L OUT 24
42 D/A
26
27
28 29
30
31
32
33
34
35
36
37
38
39
40
VCC
C VOL OUT
C OP IN
C OP NF
C OP OUT
VOL REF
S OP OUT
S OP NF
S OP IN
S VOL OUT
OP VREF
S VOL IN
S OUT
DC CUT
41 DC CUT
25
GND
R NF 22
— 21 —
IC551
LC7822 (MAIN BOARD)
30
1
IN
OUT
IN
OUT
2
29 IN
3
28
27 OUT
5
26
25 IN
7
24
23 OUT
9
22
1
NF
2
-VEOUT
5
+VEOUT
6
VSS
7
GND
8
IN
IN
21
R4
TR5
R3
D4
D1
D2
R8
R5
9
R9
TR8
CL 15
18 RESET
LATCH
CONTROL
14
17 S
SHIFT RESISTOR
16 VSS
LT1
LT2
LT3
LTOUT
LSIN
LS1
LS2
LS3
LSOUT
LC75373ED (MAIN BOARD)
33
32
31 30
29
28 27 26
25 24
23
+
–
+
–
34
35
36
37
38
+
–
22 LFIN
–
+
–
+
LSELO
L4
L3
L2
L1
–
+
–
+
+
–
21 LFOUT
+
–
20 LROUT
19 VREF
VDD 39
–
+
–
+
40
41
42
43
44
+
–
–
+
+
–
2
3 4
5
6 7 8
9 10
RCOM
RT1
RT2
RT3
RTOUT
RSIN
RS1
RS2
RS3
11
µPC2581V (MAIN BOARD)
BIAS CIRCUIT
PROTECTOR
PRE
DRIVE
PRE
DRIVE
2
3
4
5
6
7
8
9
10
11
12
13 14 15
– VOUT1
COMP1
MF1
IN1
GND
IN2
NF2
COMP2
– VOUT2
+ VOUT2
VCC1
— 22 —
VCC2
VEE
1
+ VOUT1
DRIVE
MUTE
DRIVE
18
17
16
15
CE
DI
CL
VSS
14 RROUT
13 RFOUT
12 RFIN
RVRIN
–
+
1
REG
CONTROL
–
+
+
–
–
+
IC701
SHIFT
REGISTER
LATCH
RSOUT
R1
R2
R3
R4
RSELO
DECODER
R6
TR6
19 VDD
CE 13
IC301
R2
TR7
LCOM
12
VCC
20 OUT
LEVEL SHIFT
TR4
TR2
LVRIN
VEE
DI
INPUT
4
8
11
R1
3
6
10
TR3
TR1
4
OUT
STK350-230 (MAIN BOARD)
SUB
IC101
R7
D3
SECTION 4
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
•
•
•
The mechanical parts with no reference number
in the exploded views are not supplied.
Hardware (# mark) list and accessories and
packing materials are given in the last of this
parts list.
Abbreviation
AUS : Australian model.
SP
: Singapore model.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.
4-1. FRONT PANEL SECTION
13
13
a
13
12
14
9
#1
8
22
10
15
11
16
#1
a
17
5
15
SO
NY
18
24
4
6
7
21
3
23
20
4
2
#1
#1
19
#1
#1
1
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
2
3
* 4
5
4-999-844-01
X-4949-434-3
4-979-942-13
4-982-462-01
4-963-404-02
KNOB (VOL)
PANEL ASSY, FRONT
WINDOW
HOUSE, LED
EMBLEM (5-A), SONY
Remarks
13
14
15
16
* 17
3-710-901-11
1-769-867-11
4-951-620-01
1-773-217-11
A-4407-853-A
SCREW, TAPPING
WIRE (FLAT TYPE) (5 CORE)
SCREW (2.6 × 8), +BVTP
WIRE (FLAT TYPE) (25 CORE)
DISPLAY BOARD, COMPLETE
6
7
8
* 9
* 10
4-979-941-01
4-979-935-01
4-980-109-51
1-670-206-11
4-982-814-01
BUTTON (SUR)
BUTTON (F-6)
BUTTON (P-M)
SW BOARD
LENS (SUR)
*
*
*
*
18
19
20
21
22
1-669-721-11
4-979-946-01
4-982-817-01
4-982-815-01
4-628-006-01
VOL BOARD
PLATE (432), BOTTOM
BOX (CON), LED
LENS (CON)
CUSHION
* 11
* 12
4-982-816-01 BOX (SUR), LED
4-979-945-01 CASE (414532)
23
24
4-979-937-11 FILTER (SUPER WOOFER)
4-979-937-01 FILTER (DOLBY PRO LOGIC)
— 23 —
Remarks
4-2. CHASSIS SECTION
#1
E MODEL
not supplied
53
T901
53
AEP, SP MODEL
IC601
56
63
#2
54
64
63
AUS MODEL
67
Q554
#1
#1
#1
Q703
59
Q553
Q753
Q704
57
not
supplied
63
60
Q754
#1
58
#1
72
not supplied
#1
#1
62
52
#1
not supplied
#1
not supplied
#1
#1
66
#1
61
#1
#1
#1
#1
#1
#1
51
not supplied
65
not supplied
Ref. No.
Part No.
Description
51
52
53
* 54
* 56
X-3371-405-2
4-985-642-01
4-900-386-01
1-669-720-11
1-669-719-11
* 57
58
! 59
* 60
* 60
Remarks
Ref. No.
Part No.
Description
FOOT (SMALL) ASSY
CUSHION
SCREW
TRANS 2 BOARD
TRANS 1 BOARD
! 64
* 65
* 65
* 66
* 67
1-569-007-11
A-4407-401-A
A-4407-848-A
1-669-722-11
3-703-244-00
ADAPTOR, CONVERSION 2P (E)
MAIN BOARD, COMPLETE (E,SP,AUS)
MAIN BOARD, COMPLETE (AEP)
HP BOARD
BUSHING (2104), CORD (AEP,SP,AUS)
1-669-718-11
3-905-609-01
1-526-794-11
4-992-741-31
4-992-741-41
POWER BOARD
SCREW (TRANSISTOR)
OUTLET, AC (CNJ901) (AEP,SP,AUS)
PANEL, BACK (AEP)
PANEL, BACK (E)
67
* 72
IC601
Q553
Q554
3-703-571-11
4-984-451-01
8-749-900-96
8-749-010-25
8-749-010-26
BUSHING (S) (4516), CORD (E)
PROTECTOR (E)
IC STK-4142MK2
TRANSISTOR MN2488-OPY-M
TRANSISTOR MP1620-OPY-M
* 60
* 60
* 61
* 62
! 63
4-992-741-51
4-992-741-61
1-669-716-11
1-669-723-11
1-575-651-11
PANEL, BACK (AUS)
PANEL, BACK (SP)
REAR SP BOARD
OUTLET BOARD (AEP,SP,AUS)
CORD, POWER (AEP,SP)
Q703
Q704
Q753
Q754
! T901
8-749-010-25
8-749-010-26
8-749-010-25
8-749-010-26
1-431-857-11
TRANSISTOR MN2488-OPY-M
TRANSISTOR MP1620-OPY-M
TRANSISTOR MN2488-OPY-M
TRANSISTOR MP1620-OPY-M
TRANSFORMER, POWER (AEP,SP,AUS)
! 63
! 63
1-575-653-11 CORD, POWER (E)
1-690-608-11 CORD, POWER (AUS)
! T901
1-431-858-11 TRANSFORMER, POWER (E)
— 24 —
Remarks
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
SECTION 5
ELECTRICAL PARTS LIST
DISPLAY
NOTE:
•
When indicating parts by reference number,
please include the board name.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.
•
•
•
Abbreviation
AUS : Australian model.
SP
: Singapore model.
•
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they may
have some difference from the original one.
Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
CAPACITORS:
uF: µF
Ref. No.
Part No.
*
A-4407-853-A DISPLAY BOARD, COMPLETE
********************
Description
Remarks
*
*
4-921-941-01 CUSHION (FL)
4-979-943-01 HOLDER, FL TUBE
Ref. No.
•
Description
Remarks
1-517-512-11 INDICATOR TUBE, FLUORESCENT
< IC >
< CAPACITOR >
C401
C402
C403
C404
C405
1-162-306-11
1-162-306-11
1-124-903-11
1-124-903-11
1-126-934-11
CERAMIC
CERAMIC
ELECT
ELECT
ELECT
0.01uF
0.01uF
1uF
1uF
220uF
20%
20%
20%
20%
20%
16V
16V
50V
50V
10V
C406
C407
C408
C409
C410
1-124-907-11
1-124-907-11
1-164-159-11
1-136-165-00
1-164-159-11
ELECT
ELECT
CERAMIC
FILM
CERAMIC
10uF
10uF
0.1uF
0.1uF
0.1uF
20%
20%
50V
50V
50V
50V
50V
C411
C412
C413
C414
1-164-159-11
1-161-494-00
1-162-294-31
1-161-494-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.022uF
0.001uF
0.022uF
5%
10%
50V
25V
50V
25V
< CONNECTOR >
1-568-848-11
1-568-867-11
1-750-194-11
1-770-397-11
1-568-662-11
•
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: µH
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
< FILTER >
FL401
* CN401
* CN402
CN403
CN405
CN408
Part No.
•
SOCKET, CONNECTOR 5P
SOCKET, CONNECTOR 25P
CONNECTOR, BOARD TO BOARD 4P
HOUSING, CONNECTOR(PC BOARD)4P
CONNECTOR, BOARD TO BOARD 6P
< DIODE >
D401
D402
D403
D404
D406
8-719-118-51
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
RD3.9F-T7B1
1SS119
1SS119
1SS119
1SS119
D407
D408
D409
D410
D411
D412
D413
D414
D415
D416
8-719-313-45
8-719-313-45
8-719-313-45
8-719-313-45
8-719-032-98
8-719-032-98
8-719-032-98
8-719-032-98
8-719-313-45
8-719-313-45
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
SEL6810A-TH10 (TONE)
SEL6810A-TH10 (CENTER)
SEL6810A-TH10 (REAR)
SEL6810A-TH10 (WOOFER)
SEL5820A (SUPER WOOFER)
SEL5820A (SUPER WOOFER)
SEL5820A (DOLBY PRO LOGIC)
SEL5820A (DOLBY PRO LOGIC)
SEL6810A-TH10 (DOLBY)
SEL6810A-TH10 (HALL)
D417
D418
D419
8-719-313-45 DIODE SEL6810A-TH10 (SIMULATED)
8-719-313-45 DIODE SEL6810A-TH10 (STANDBY)
8-719-911-19 DIODE 1SS119
IC401
IC402
IC403
8-759-564-52 IC uPD78042FGF-089-3B9
8-759-165-81 IC PST600D-T
8-759-373-49 IC NJL54H400
< TRANSISTOR >
Q401
Q402
Q403
Q404
8-729-119-78
8-729-900-63
8-729-900-36
8-729-900-63
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC403SP-51
DTA124ES
DTC124ES
DTA124ES
< RESISTOR >
R401
R402
R403
R404
R405
1-249-429-11
1-249-429-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R406
R407
R408
R409
R410
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R421
R422
R423
R424
R425
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R426
R427
R428
R429
R430
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R431
R432
R433
R434
R435
1-249-437-11
1-249-437-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R436
R437
R438
R439
R440
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
— 25 —
DISPLAY
Ref. No.
HP
MAIN
Part No.
Description
Part No.
Description
R441
R442
R443
R444
R445
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
Remarks
Ref. No.
S412
S413
S414
S415
S416
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (WOOFER ON/OFF)
SWITCH, KEYBOARD (1 LOCK)
SWITCH, KEYBOARD (2 POPS)
SWITCH, KEYBOARD (3 CLASSIC)
SWITCH, KEYBOARD (4 MODE)
Remarks
R446
R447
R448
R449
R450
1-247-807-31
1-249-429-11
1-249-429-11
1-249-429-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
10K
10K
10K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
S417
S418
S419
S420
S421
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (5 GAME)
SWITCH, KEYBOARD (PHONO)
SWITCH, KEYBOARD (TUNER)
SWITCH, KEYBOARD (CD)
SWITCH, KEYBOARD (TAPE)
R451
R452
R453
R454
R455
1-249-437-11
1-249-429-11
1-249-429-11
1-247-903-00
1-249-409-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
10K
10K
1M
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
S422
S423
1-762-875-21 SWITCH, KEYBOARD (VIDEO 2)
1-762-875-21 SWITCH, KEYBOARD (VIDEO 1)
R456
R457
R458
R459
R460
1-249-402-11
1-249-402-11
1-249-409-11
1-249-409-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
56
56
220
220
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R461
R462
R463
R464
R465
1-249-419-11
1-249-401-11
1-249-403-11
1-247-807-31
1-249-407-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
47
68
100
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
R467
R468
R469
R470
R471
1-249-420-11
1-249-417-11
1-249-419-11
1-249-421-11
1-247-843-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.8K
1K
1.5K
2.2K
3.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R472
R473
R474
R475
R476
1-249-427-11
1-249-431-11
1-249-419-11
1-249-401-11
1-249-403-11
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
15K
1.5K
47
68
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
R477
R478
R479
R480
R481
1-247-807-31
1-249-407-11
1-249-407-11
1-249-409-11
1-249-411-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
150
150
220
330
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W F
1/4W
R482
R483
R484
R485
R486
1-249-413-11
1-249-415-11
1-249-417-11
1-249-409-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
680
1K
220
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R487
1-249-429-11 CARBON
10K
5%
1/4W
< VIBRATOR >
X401
1-579-233-11 VIBRATOR, CERAMIC 5MHz
************************************************************
1-669-722-11 HP BOARD
********
*
< CAPACITOR >
C415
C416
C465
1-162-302-11 CERAMIC
1-164-159-11 CERAMIC
1-162-302-11 CERAMIC
0.0022uF 30%
0.1uF
0.0022uF 30%
16V
50V
16V
F
< CONNECTOR >
< SWITCH >
S402
S403
S404
S405
S406
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (CENTER MODE)
SWITCH, KEYBOARD (DOLBY)
SWITCH, KEYBOARD (HALL)
SWITCH, KEYBOARD (SIMULATED)
SWITCH, KEYBOARD (+)
S407
S408
S409
S410
S411
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (-)
SWITCH, KEYBOARD (TONE)
SWITCH, KEYBOARD (CENTER)
SWITCH, KEYBOARD (REAR)
SWITCH, KEYBOARD (WOOFER)
F
F
F
F
F
F
F
CN406
1-770-388-11 PIN, CONNECTOR (PC BOARD) 4P
< JACK >
J401
1-569-113-11 JACK, LARGE TYPE (PHONES)
************************************************************
A-4407-401-A MAIN BOARD, COMPLETE (E,SP,AUS)
******************************
A-4407-848-A MAIN BOARD, COMPLETE (AEP)
**************************
*
*
7-685-646-01 SCREW +BVTP
3 × 8 TYPE1
< CAPACITOR >
C101
C102
C103
C104
C105
1-126-963-11
1-162-282-31
1-126-964-11
1-137-437-11
1-137-365-11
ELECT
CERAMIC
ELECT
FILM
FILM
4.7uF
100PF
10uF
0.0056uF
0.0015uF
20%
10%
20%
5%
5%
50V
50V
50V
50V
50V
C106
C107
C109
C115
C116
1-126-960-11
1-164-159-11
1-162-294-31
1-126-964-11
1-126-961-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
1uF
0.1uF
0.001uF
10uF
2.2uF
20%
10%
20%
20%
50V
50V
50V
50V
50V
C117
C118
C121
C122
C131
1-136-165-00
1-136-165-00
1-126-960-11
1-126-964-11
1-126-963-11
FILM
FILM
ELECT
ELECT
ELECT
0.1uF
0.1uF
1uF
10uF
4.7uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C132
C151
C152
C153
C154
1-126-961-11
1-126-963-11
1-162-282-31
1-126-964-11
1-137-437-11
ELECT
ELECT
CERAMIC
ELECT
FILM
2.2uF
4.7uF
100PF
10uF
0.0056uF
20%
20%
10%
20%
5%
50V
50V
50V
50V
50V
— 26 —
MAIN
Ref. No.
Part No.
Description
C155
C156
C157
C158
C159
1-137-365-11
1-126-960-11
1-164-159-11
1-162-291-31
1-136-165-00
FILM
ELECT
CERAMIC
CERAMIC
FILM
0.0015uF
1uF
0.1uF
560PF
0.1uF
5%
20%
Remarks
Part No.
Description
10%
5%
50V
50V
50V
50V
50V
C214
C215
C216
C217
C218
1-136-165-00
1-126-964-11
1-126-961-11
1-136-165-00
1-136-165-00
FILM
ELECT
ELECT
FILM
FILM
C221
C222
C231
C232
C300
1-126-960-11
1-126-964-11
1-126-963-11
1-126-961-11
1-126-961-11
C301
C302
C303
C304
C305
Ref. No.
C347
C348
C349
C350
C351
1-126-962-11
1-136-167-00
1-126-963-11
1-126-961-11
1-126-933-11
ELECT
FILM
ELECT
ELECT
ELECT
3.3uF
0.15uF
4.7uF
2.2uF
100uF
20%
5%
20%
20%
20%
50V
50V
50V
50V
16V
0.1uF
10uF
2.2uF
0.1uF
0.1uF
5%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C352
C353
C354
C355
C356
1-128-551-11
1-162-294-31
1-137-193-11
1-126-960-11
1-126-934-11
ELECT
CERAMIC
FILM
ELECT
ELECT
22uF
0.001uF
0.39uF
1uF
220uF
20%
10%
5%
20%
20%
25V
50V
50V
50V
10V
ELECT
ELECT
ELECT
ELECT
ELECT
1uF
10uF
4.7uF
2.2uF
2.2uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C357
C360
C361
C362
C363
1-136-177-00
1-126-964-11
1-128-551-11
1-126-960-11
1-126-960-11
FILM
ELECT
ELECT
ELECT
ELECT
1uF
10uF
22uF
1uF
1uF
5%
20%
20%
20%
20%
50V
50V
25V
50V
50V
1-126-963-11
1-126-959-11
1-126-964-11
1-126-964-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
0.47uF
10uF
10uF
10uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C364
C365
C369
C370
C371
1-137-367-11
1-136-157-00
1-126-963-11
1-126-964-11
1-128-551-11
FILM
FILM
ELECT
ELECT
ELECT
0.0033uF
0.022uF
4.7uF
10uF
22uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
25V
C306
C307
C308
C309
C310
1-126-964-11
1-126-934-11
1-126-934-11
1-136-165-00
1-126-961-11
ELECT
ELECT
ELECT
FILM
ELECT
10uF
220uF
220uF
0.1uF
2.2uF
20%
20%
20%
5%
20%
50V
10V
10V
50V
50V
C372
C374
C375
C379
C385
1-126-960-11
1-137-367-11
1-136-157-00
1-126-963-11
1-126-960-11
ELECT
FILM
FILM
ELECT
ELECT
1uF
0.0033uF
0.022uF
4.7uF
1uF
20%
5%
5%
20%
20%
50V
50V
50V
50V
50V
C311
C312
C313
C314
C315
1-126-934-11
1-126-961-11
1-126-960-11
1-126-959-11
1-126-934-11
ELECT
ELECT
ELECT
ELECT
ELECT
220uF
2.2uF
1uF
0.47uF
220uF
20%
20%
20%
20%
20%
10V
50V
50V
50V
10V
C386
C387
C501
C502
C503
1-126-964-11
1-136-165-00
1-164-159-11
1-162-286-31
1-162-286-31
ELECT
FILM
CERAMIC
CERAMIC
CERAMIC
10uF
0.1uF
0.1uF
220PF
220PF
20%
5%
10%
10%
50V
50V
50V
50V
50V
C316
C317
C318
C319
C320
1-136-165-00
1-136-165-00
1-126-964-11
1-126-961-11
1-126-964-11
FILM
FILM
ELECT
ELECT
ELECT
0.1uF
0.1uF
10uF
2.2uF
10uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C508
C510
C511
C512
C514
1-137-193-11
1-126-959-11
1-136-166-00
1-126-964-11
1-104-665-11
FILM
ELECT
FILM
ELECT
ELECT
0.39uF
0.47uF
0.12uF
10uF
100uF
5%
20%
5%
20%
20%
50V
50V
50V
50V
10V
C321
C322
C323
C324
C325
1-136-165-00
1-126-961-11
1-124-252-00
1-126-959-11
1-136-164-00
FILM
ELECT
ELECT
ELECT
FILM
0.1uF
2.2uF
0.33uF
0.47uF
0.082uF
5%
20%
20%
20%
5%
50V
50V
50V
50V
50V
C515
C516
C540
C551
C552
1-126-964-11
1-126-964-11
1-128-560-11
1-126-963-11
1-162-282-31
ELECT
ELECT
ELECT
ELECT
CERAMIC
10uF
10uF
22uF
4.7uF
100PF
20%
20%
20%
20%
10%
50V
50V
100V
50V
50V
C326
C327
C328
C329
C330
1-137-367-11
1-136-164-00
1-136-165-00
1-126-934-11
1-130-469-00
FILM
FILM
FILM
ELECT
MYLAR
0.0033uF
0.082uF
0.1uF
220uF
680PF
5%
5%
5%
20%
5%
50V
50V
50V
10V
50V
C553
C554
C555
C556
C560
1-126-934-11
1-162-194-31
1-102-989-00
1-136-275-11
1-104-664-11
ELECT
CERAMIC
CERAMIC
FILM
ELECT
220uF
3.9PF
68PF
390PF
47uF
20%
10%
5%
5%
20%
10V
50V
500V
630V
16V
C331
C332
C333
C334
C335
1-136-161-00
1-136-157-00
1-136-173-00
1-104-664-11
1-126-960-11
FILM
FILM
FILM
ELECT
ELECT
0.047uF
0.022uF
0.47uF
47uF
1uF
5%
5%
5%
20%
20%
50V
50V
50V
16V
50V
C561
C570
C601
C602
C603
1-137-372-11
1-162-286-31
1-126-963-11
1-162-286-31
1-104-664-11
FILM
CERAMIC
ELECT
CERAMIC
ELECT
0.022uF
220PF
4.7uF
220PF
47uF
5%
10%
20%
10%
20%
50V
50V
50V
50V
25V
C336
C337
C339
C340
C341
1-128-551-11
1-136-165-00
1-126-959-11
1-126-963-11
1-126-959-11
ELECT
FILM
ELECT
ELECT
ELECT
22uF
0.1uF
0.47uF
4.7uF
0.47uF
20%
5%
20%
20%
20%
25V
50V
50V
50V
50V
C604
C605
C606
C607
C608
1-162-191-31
1-162-286-31
1-126-967-11
1-126-968-11
1-126-968-11
CERAMIC
CERAMIC
ELECT
ELECT
ELECT
2.2PF
220PF
47uF
100uF
100uF
10%
10%
20%
20%
20%
50V
50V
50V
50V
50V
C342
C343
C344
C345
C346
1-126-963-11
1-136-167-00
1-126-962-11
1-136-167-00
1-136-167-00
ELECT
FILM
ELECT
FILM
FILM
4.7uF
0.15uF
3.3uF
0.15uF
0.15uF
20%
5%
20%
5%
5%
50V
50V
50V
50V
50V
C611
C612
C613
C620
C651
1-136-163-00
1-136-163-00
1-126-964-11
1-164-159-11
1-126-963-11
FILM
FILM
ELECT
CERAMIC
ELECT
0.068uF
0.068uF
10uF
0.1uF
4.7uF
5%
5%
20%
50V
50V
50V
50V
50V
— 27 —
Remarks
20%
MAIN
Ref. No.
Part No.
Description
C652
C653
C654
C655
C656
1-162-286-31
1-104-664-11
1-162-191-31
1-162-286-31
1-126-967-11
CERAMIC
ELECT
CERAMIC
CERAMIC
ELECT
220PF
47uF
2.2PF
220PF
47uF
10%
20%
10%
10%
20%
Remarks
50V
25V
50V
50V
50V
C657
C658
C659
C661
C662
1-126-965-11
1-126-968-11
1-126-968-11
1-136-163-00
1-136-163-00
ELECT
ELECT
ELECT
FILM
FILM
22uF
100uF
100uF
0.068uF
0.068uF
20%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C670
C702
C703
C705
C710
1-164-159-11
1-162-290-31
1-126-964-11
1-102-233-00
1-104-664-11
CERAMIC
CERAMIC
ELECT
CERAMIC
ELECT
0.1uF
470PF
10uF
33PF
47uF
10%
20%
10%
20%
50V
50V
50V
500V
16V
C711
C720
C721
C722
C740
1-137-372-11
1-162-286-31
1-126-934-11
1-126-965-11
1-128-552-51
FILM
CERAMIC
ELECT
ELECT
ELECT
0.022uF
220PF
220uF
22uF
47uF
5%
10%
20%
20%
20%
50V
50V
10V
50V
63V
C741
C742
C752
C753
C755
1-128-552-51
1-126-934-11
1-162-290-31
1-126-964-11
1-102-233-00
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
47uF
220uF
470PF
10uF
33PF
20%
20%
10%
20%
10%
63V
10V
50V
50V
500V
C760
C761
C770
C771
C772
1-104-664-11
1-137-372-11
1-162-286-31
1-164-159-11
1-137-372-11
ELECT
FILM
CERAMIC
CERAMIC
FILM
47uF
0.022uF
220PF
0.1uF
0.022uF
20%
5%
10%
5%
16V
50V
50V
50V
50V
C801
C802
C803
C804
C805
1-126-967-11
1-126-967-11
1-117-782-11
1-117-782-11
1-130-781-00
ELECT
ELECT
ELECT
ELECT
FILM
47uF
47uF
6800uF
6800uF
0.22uF
20%
20%
20%
20%
10%
50V
50V
63V
63V
100V
C806
C807
C808
C809
C810
1-130-781-00
1-104-664-11
1-104-664-11
1-126-960-11
1-126-960-11
FILM
ELECT
ELECT
ELECT
ELECT
0.22uF
47uF
47uF
1uF
1uF
10%
20%
20%
20%
20%
100V
16V
16V
50V
50V
C811
1-126-944-11 ELECT
3300uF
20%
C811
1-126-946-11 ELECT
6800uF
C812
C813
C814
1-126-940-11 ELECT
1-164-088-11 CERAMIC
1-164-088-11 CERAMIC
330uF
0.001uF
0.001uF
25V
(AEP)
20%
25V
(E,SP,AUS)
20%
25V
50V
50V
C820
C821
C822
C823
1-137-397-11
1-137-397-11
1-126-974-11
1-126-974-11
0.047uF
0.047uF
3300uF
3300uF
5%
5%
20%
20%
Ref. No.
Part No.
Description
Remarks
< DIODE >
D521
D522
D523
D560
D601
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
1SS119
1SS119
D610
D651
D710
D711
D721
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
1SS119
1SS119
D722
D723
D724
D725
D726
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
1SS119
1SS119
1SS119
1SS119
D727
D801
D802
D803
D818
8-719-911-19
8-719-986-60
8-719-510-68
8-719-510-68
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119
HZS27-3LTA
D5SBA20F01
D5SBA20F01
1SS119
D820
D821
D822
D823
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
< EARTH >
* EB901
1-537-738-21 TERMINAL, EARTH
< FERRITE BEAD >
FILM
FILM
ELECT
ELECT
100V
100V
50V
50V
FB341
1-770-721-11 CONNECTOR, BOARD TO BOARD 4P
1-568-841-11 SOCKET, CONNECTOR 25P
0UH
< IC >
IC101
IC102
IC300
IC301
IC303
8-759-805-14
8-759-634-50
8-759-526-39
8-759-443-67
8-759-634-51
IC
IC
IC
IC
IC
LC7822
M5218AL
LV1041M
LC75373ED
M5218AP
IC501
IC502
IC551
IC601
IC701
8-759-634-51
8-759-634-51
8-749-011-16
8-749-900-96
8-759-326-52
IC
IC
IC
IC
IC
M5218AP
M5218AP
STK350-230
STK-4142MK2
uPC2581V
IC801
IC802
8-759-604-32 IC M5F7810
8-759-604-50 IC M5F7910
< JACK >
J101
J102
1-766-558-41 JACK, PIN 8P (PHONO/TUNER/CD/TAPE OUT)
1-766-558-31 JACK, PIN 8P (TAPE IN/VIDEO 2/VIDEO 1)
< COIL >
< CONNECTOR >
CN102
* CN501
1-412-473-21 INDUCTOR
L341
— 28 —
1-410-521-11 INDUCTOR
100uH
MAIN
Ref. No.
Part No.
Description
Remarks
< TRANSISTOR >
Q121
Q131
Q221
Q231
Q331
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2144S
2SD2144S
2SD2144S
2SD2144S
2SD2144S
Q332
Q381
Q382
Q502
Q503
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2144S
2SD2144S
2SD2144S
2SD2144S
2SD2144S
Q551
Q552
Q553
Q554
Q560
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1175-HFE
2SC3623A-LK
MN2488-OPY-M
MP1620-OPY-M
2SC403SP-51
Q570
Q610
Q620
Q670
Q701
8-729-140-82
8-729-119-78
8-729-140-82
8-729-140-82
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988-PAFAEA
2SC403SP-51
2SA988-PAFAEA
2SA988-PAFAEA
2SA1175-HFE
Q702
Q703
Q704
Q710
Q711
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
MN2488-OPY-M
MP1620-OPY-M
2SC403SP-51
2SC403SP-51
Q720
Q721
Q722
Q723
Q740
8-729-140-82
8-729-140-82
8-729-140-84
8-729-119-78
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988-PAFAEA
2SA988-PAFAEA
2SC1841-PAFAEA
2SC403SP-51
2SC1841-PAFAEA
Q751
Q752
Q753
Q754
Q770
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-140-82
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1175-HFE
2SC3623A-LK
MN2488-OPY-M
MP1620-OPY-M
2SA988-PAFAEA
Q801
Q803
8-729-030-19 TRANSISTOR 2SB1640
8-729-119-78 TRANSISTOR 2SC403SP-51
Ref. No.
Part No.
Description
R131
R132
R134
R151
R152
1-249-429-11
1-249-421-11
1-249-429-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
2.2K
10K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W F
Remarks
R153
R154
R155
R156
R157
1-249-425-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R158
R159
R160
R161
R162
1-249-417-11
1-249-427-11
1-249-437-11
1-249-415-11
1-247-897-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
6.8K
47K
680
560K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
1/4W
R163
R164
R165
R201
R202
1-249-437-11
1-249-409-11
1-249-441-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
220
100K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W F
R203
R204
R221
R222
R223
1-249-441-11
1-249-441-11
1-249-433-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
22K
100K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R224
R231
R232
R234
R301
1-249-441-11
1-249-429-11
1-249-421-11
1-249-429-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
10K
2.2K
10K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R302
R303
R304
R305
R306
1-249-433-11
1-249-436-11
1-247-903-00
1-249-409-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
22K
39K
1M
220
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R307
R308
R309
R310
R311
1-247-807-31
1-247-807-31
1-247-807-31
1-247-844-11
1-247-843-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
3.6K
3.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R321
R322
R323
R324
R325
1-249-430-11
1-249-433-11
1-249-417-11
1-249-433-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
12K
22K
1K
22K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R326
R327
R328
R331
R332
1-249-417-11
1-249-441-11
1-249-421-11
1-249-441-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
2.2K
100K
2.2K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W F
R334
R362
R363
R364
R365
1-249-429-11
1-249-441-11
1-249-441-11
1-249-421-11
1-249-411-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
100K
2.2K
330
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R366
R367
R369
R371
R372
1-249-421-11
1-249-411-11
1-249-409-11
1-249-430-11
1-249-433-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
330
220
12K
22K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W
F
F
F
F
F
< RESISTOR >
R101
R102
R103
R104
R105
1-249-417-11
1-249-417-11
1-249-425-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
4.7K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R106
R107
R108
R109
R110
1-249-417-11
1-249-417-11
1-249-417-11
1-249-427-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
6.8K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R111
R112
R113
R114
R115
1-249-415-11
1-247-897-11
1-249-437-11
1-249-409-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
560K
47K
220
100K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W
R116
R121
R122
R123
R124
1-249-425-11
1-249-433-11
1-249-441-11
1-249-417-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
22K
100K
1K
100K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W
— 29 —
MAIN
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
Description
R373
R374
R375
R376
R377
1-249-417-11
1-249-433-11
1-249-441-11
1-249-417-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
22K
100K
1K
100K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W
R602
R603
R604
R605
R606
1-249-438-11
1-249-412-11
1-249-438-11
1-260-103-11
1-260-103-11
CARBON
CARBON
CARBON
CARBON
CARBON
56K
390
56K
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/2W
1/2W
R378
R381
R382
R384
R395
1-249-421-11
1-249-441-11
1-249-421-11
1-249-429-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100K
2.2K
10K
100K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W
! R607
R608
R609
! R616
R618
1-249-405-11
1-260-099-11
1-260-099-11
1-208-602-11
1-249-393-11
CARBON
CARBON
CARBON
METAL
CARBON
100
1K
1K
0.22
10
5%
5%
5%
5%
1/4W F
1/2W
1/2W
2W
1/4W F
R399
R501
R502
R503
R504
1-249-441-11
1-247-807-31
1-247-807-31
1-247-807-31
1-249-418-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100
100
100
1.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R621
R622
R623
R624
R630
1-249-417-11
1-249-433-11
1-249-437-11
1-215-867-00
1-249-429-11
CARBON
CARBON
CARBON
METAL OXIDE
CARBON
1K
22K
47K
470
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1W
F
1/4W
R505
R506
R517
R518
1-249-418-11
1-249-418-11
1-249-441-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
1.2K
1.2K
100K
100K
5%
5%
5%
5%
R651
R652
R653
R654
R655
1-249-417-11
1-249-438-11
1-249-411-11
1-249-438-11
1-260-103-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
56K
330
56K
2.2K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/2W
R519
1-249-429-11 CARBON
10K
5%
1/4W F
1/4W F
1/4W
1/4W
(AEP)
1/4W
R520
R521
1-249-415-11 CARBON
1-247-887-00 CARBON
680
220K
5%
5%
1-247-883-00 CARBON
150K
5%
R656
! R657
! R666
R668
R671
1-260-103-11
1-249-405-11
1-208-602-11
1-249-393-11
1-249-417-11
CARBON
CARBON
METAL
CARBON
CARBON
2.2K
100
0.22
10
1K
5%
5%
R521
5%
5%
1/2W
1/4W F
2W
1/4W F
1/4W F
R523
R524
1-249-427-11 CARBON
1-249-432-11 CARBON
6.8K
18K
5%
5%
1/4W F
1/4W
(AEP)
1/4W
(E,SP,AUS)
1/4W F
1/4W
R529
R530
R531
R532
R533
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R672
R673
R701
R702
R703
1-249-433-11
1-249-437-11
1-249-417-11
1-249-439-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
47K
1K
68K
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
R535
R536
R537
R538
1-249-441-11
1-249-429-11
1-249-421-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
100K
10K
2.2K
100K
5%
5%
5%
5%
R704
R710
R711
R713
! R714
1-249-439-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-408-11
CARBON
CARBON
CARBON
CARBON
CARBON
68K
2.2K
47K
560
180
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W F
! R715
! R716
! R717
! R718
R720
1-249-408-11
1-208-602-11
1-208-602-11
1-249-393-11
1-249-419-11
CARBON
METAL
METAL
CARBON
CARBON
180
0.22
0.22
10
1.5K
5%
5%
5%
1/4W F
2W
2W
1/4W F
1/4W F
R721
R722
R723
R724
R725
1-249-427-11
1-215-867-00
1-249-437-11
1-249-429-11
1-249-429-11
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
6.8K
470
47K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1W
F
1/4W
1/4W
1/4W
R726
R727
R728
R729
R730
1-249-417-11
1-249-427-11
1-249-419-11
1-249-419-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
6.8K
1.5K
1.5K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R732
! R740
! R741
R742
R744
1-249-429-11
1-249-393-11
1-249-393-11
1-249-417-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10
10
1K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
! R540
1-249-405-11 CARBON
100
5%
1/4W
1/4W
1/4W F
1/4W
(E,SP,AUS)
1/4W F
! R541
R551
R552
R553
R554
1-249-405-11
1-249-417-11
1-249-438-11
1-249-417-11
1-249-438-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
1K
56K
1K
56K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
1/4W
R555
R560
R561
R563
! R564
1-249-413-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-408-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
2.2K
47K
560
180
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
! R565
! R566
! R567
! R568
R570
1-249-408-11
1-208-602-11
1-208-602-11
1-249-393-11
1-249-419-11
CARBON
METAL
METAL
CARBON
CARBON
180
0.22
0.22
10
1.5K
5%
5%
5%
1/4W F
2W
2W
1/4W F
1/4W F
R571
R572
R573
R580
R601
1-249-427-11
1-215-867-00
1-249-437-11
1-249-429-11
1-249-417-11
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
6.8K
470
47K
10K
1K
5%
5%
5%
5%
5%
1/4W F
1W
F
1/4W
1/4W
1/4W F
F
F
F
F
— 30 —
Remarks
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
F
F
F
F
F
F
F
F
MAIN
Ref. No.
Remarks
Part No.
Description
1-249-435-11
1-249-417-11
1-249-439-11
1-249-413-11
1-249-439-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
1K
68K
470
68K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W
R760
R761
R763
! R764
! R765
1-249-421-11
1-249-425-11
1-249-414-11
1-249-408-11
1-249-408-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
4.7K
560
180
180
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
! R766
! R767
! R768
! R770
R771
1-208-602-11
1-208-602-11
1-249-393-11
1-249-419-11
1-249-427-11
METAL
METAL
CARBON
CARBON
CARBON
0.22
0.22
10
1.5K
6.8K
5%
5%
5%
2W
2W
1/4W F
1/4W F
1/4W F
D951
D952
D953
D954
D955
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-911-19
R772
R773
R778
R779
! R803
1-215-867-00
1-249-437-11
1-249-419-11
1-249-419-11
1-249-389-11
METAL OXIDE
CARBON
CARBON
CARBON
CARBON
470
47K
1.5K
1.5K
4.7
5%
5%
5%
5%
5%
1W
1/4W
1/4W
1/4W
1/4W
D956
8-719-985-95 DIODE HZS7A2LTA
R804
R805
R806
R807
R823
1-249-421-11
1-215-867-00
1-249-436-11
1-249-436-11
1-249-437-11
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
2.2K
470
39K
39K
47K
5%
5%
5%
5%
5%
1/4W F
1W
F
1/4W
1/4W
1/4W
R824
1-249-425-11 CARBON
4.7K
5%
1/4W F
REAR SP
Description
Remarks
< CONNECTOR >
CN904
CN905
! CN906
* CN907
CN909
1-564-321-00
1-564-321-00
1-540-042-11
1-568-824-11
1-564-321-00
* CN911
1-564-687-11 PIN, CONNECTOR 3P (E)
PIN, CONNECTOR 2P (AEP,SP,AUS)
PIN, CONNECTOR 2P
OUTLET, AC (NONPOLAR) (3P)(E)
SOCKET, CONNECTOR 5P
PIN, CONNECTOR 2P (AEP,SP,AUS)
< DIODE >
F
F
F
F
Part No.
POWER
R745
R751
R752
R753
R754
F
F
F
F
F
Ref. No.
OUTLET
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
1SS119
< FUSE >
! F903
1-532-502-31 FUSE TIME LAG 1.25A (AEP,SP,AUS)
< TRANSISTOR >
Q901
Q902
8-729-119-78 TRANSISTOR 2SC403SP-51
8-729-026-68 TRANSISTOR 2SD2525(TP)
< RESISTOR >
R951
R952
R953
< RELAY >
RY551
RY601
RY701
RY702
RY801
1-515-920-11
1-515-920-11
1-515-920-11
1-515-920-11
1-755-026-11
RELAY (24V)
RELAY (24V)
RELAY (24V)
RELAY (24V)
RELAY
1-249-421-11 CARBON
1-249-425-11 CARBON
1-249-437-11 CARBON
2.2K
4.7K
47K
5%
5%
5%
1/4W F
1/4W F
1/4W
< RELAY >
! RY951
1-755-018-11 RELAY
< SWITCH >
< TERMINAL >
! S902
TM701
1-571-309-11 SWITCH (VOLTAGE SELECTOR)(E)
1-694-055-11 TERMINAL BOARD (SPEAKARS)
< TRANSFORMER >
< VIBRATOR >
X301
1-579-952-11 VIBRATOR, CERAMIC 8MHz
************************************************************
! T902
1-450-358-11 TRANSFORMER, POWER
************************************************************
1-669-716-11 REAR SP BOARD
*************
*
*
1-669-723-11 OUTLET BOARD (AEP,SP,AUS)
************************
< CONNECTOR >
************************************************************
CN103
*
1-669-718-11 POWER BOARD
***********
< TERMINAL >
1-533-293-11 FUSE HOLDER
TM601
1-537-240-11 TERMINAL BOARD(CHECKER PIN)
(REAR SPEAKERS)
************************************************************
< CAPACITOR >
! C951
C952
C953
C954
C955
1-113-925-11
1-137-372-11
1-126-942-61
1-126-964-11
1-126-964-11
CERAMIC
FILM
ELECT
ELECT
ELECT
1-770-725-11 CONNECTOR, BOARD TO BOARD 4P
0.01uF
0.022uF
1000uF
10uF
10uF
20%
5%
20%
20%
20%
250V
50V
25V
50V
50V
— 31 —
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
TA-AV581
SW
TRANS 1
TRANS 2
Ref. No.
Part No.
*
1-670-206-11 SW BOARD
********
VOL
Description
Remarks
14
16
! 59
* 62
! 63
1-568-668-11 CONNECTOR, BOARD TO BOARD 6P
< SWITCH >
S401
1-554-118-00 SWITCH, PUSH (1 KEY)(POWER)
************************************************************
1-669-719-11 TRANS 1 BOARD
*************
*
Part No.
Description
Remarks
MISCELLANEOUS
*************
< CONNECTOR >
CN407
Ref. No.
1-769-867-11
1-773-217-11
1-526-794-11
1-669-723-11
1-575-651-11
WIRE (FLAT TYPE) (5 CORE)
WIRE (FLAT TYPE) (25 CORE)
OUTLET, AC (AEP,SP,AUS)
OUTLET BOARD (CNJ901) (AEP,SP,AUS)
CORD, POWER (AEP,SP)
! 63
1-575-653-11 CORD, POWER (E)
! 63
1-690-608-11 CORD, POWER (AUS)
! 64
1-569-007-11 ADAPTOR, CONVERSION 2P (E)
! T901
1-431-857-11 TRANSFORMER, POWER (AEP,SP,AUS)
! T901
1-431-858-11 TRANSFORMER, POWER (E)
************************************************************
1-533-293-11 FUSE HOLDER
ACCESSORIES & PACKING MATERIALS
*******************************
< FUSE >
! F901
1-532-464-31 FUSE TIME LAG 2.5A (AEP,SP,AUS)
! F901
1-532-504-31 FUSE TIME LAG 4A (E)
! F902
1-532-388-31 FUSE TIME LAG 2A (E)
************************************************************
1-475-747-11 REMOTE COMMANDER (RM-U581)
3-810-504-31 MANUAL, INSTRUCTION
(ENGLISH,FRENCH,SPANISH,PORTUGUESE)(AEP)
3-810-504-41 MANUAL, INSTRUCTION
(GERMAN,DUTCH,SWEDISH,ITALIAN)(AEP)
3-862-620-11 MANUAL, INSTRUCTION
(ENGLISH,FRENCH,SPANISH)
3-862-620-21 MANUAL, INSTRUCTION
(GERMAN,PORTUGUESE,DUTCH,SWEDISH,ITALIAN)(AEP)
1-669-720-11 TRANS 2 BOARD
*************
*
1-533-293-11 FUSE HOLDER
< CAPACITOR >
C817
1-136-165-00 FILM
0.1uF
5%
50V
3-862-620-31 MANUAL, INSTRUCTION (CHINESE,ARABIC)
(E,SP)
4-981-643-01 BATTERY COVER (FOR RM-U581)
************************************************************
< CONNECTOR >
* CN902
**************
HARDWARE LIST
**************
1-691-774-11 PLUG (MICRO CONNECTOR) 12P
< FUSE >
! F801
! F802
#1
#2
#3
#4
1-532-505-31 FUSE TIME LAG 5A
1-532-505-31 FUSE TIME LAG 5A
7-685-646-79
7-685-650-91
7-685-646-01
7-623-954-01
SCREW +BVTP 3 × 8 TYPE2 TT(B)
SCREW +BVTP 3 × 16 TYPE2 TT(B)
SCREW +BVTP 3 × 8 TYPE1
WASHER (FIBER)
< RESISTOR >
! R810
1-217-637-00 FUSIBLE
1
5%
1/4W F
! R811
1-217-637-00 FUSIBLE
1
5%
1/4W F
************************************************************
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
1-669-721-11 VOL BOARD
*********
*
< CONNECTOR >
CN404
1-750-185-11 CONNECTOR, BOARD TO BOARD 4P
< VARIABLE RESISTOR >
RV401 1-473-392-11 ENCODER, ROTARY (MASTER VOLUME)
************************************************************
Sony Corporation
9-922-929-11
Home A&V Products Company
— 32 —
98F1664-1
Printed in Japan ©1998.6
Published by Quality Assurance Dept.
(Shibaura)