Download SERVICE MANUAL

 SERVICE MANUAL 6M62E CHASSIS Design and specifications are subject to change without prior notice. (Only Referrence) Description: SERVICE MANUAL 6M62E MODEL. Brand Name: JOB NO. Engineering Dept: Artwork By: 陈建忠 Date: 2013‐8‐29
Checked By: Date: Approved By: Date: SIZE:A5 CONTENT CONTENT ‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐2 Technical Specification‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐3‐14 Block Diagram ‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐15 List of key parts‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐16 IC BLOCK Diagram‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐17‐31 MAIN PCB‐TOP‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐32 MAIN PCB‐BOT‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐33 Circuit Diagrams‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐‐34‐42 Technical Specification 1. Application Area: This product standard is use for LED 6M61E chassis. 2. Specification: All the standard are measured under following conditions without other specification. 2.1 Ambient Temperature: 20+/‐5℃
2.2 Relative Humidity: 65+‐10％ 2.3 Power Supply Voltage: Standard Input Voltage(100～240V AC 50/60HZ) 2.4 Adjust after 20 minutes warm‐up. 3. Test and check method: 3.1 Capability: According to nation test standard 3.2 Safety:______________________________standard 3.3 EMC:________________________________standard Technical Specification 4. Safety and Regulation NO. 1. 2. 3. 4. Item Min
Typ Max Unit Remark Force Stability‐Inclineplane Tip Test 10 deg Force Stability‐Level Tip Test 100 N Isolation Gap AC‐AC/AC‐DC 3 mm Isolation Gap 6 mm W W W W Power consumtion Standby 1 W Dielectric Voltage 3 kV Isolation Resistance 4 MΩ Leakage Current 5 mApp Power cord captivity 40 N Flammability—Back Cover PASS Sharp edge PASS UL Compliance NO FCC Compliance NO CDRH Radiation Compliance NO CSA Compliance NO CEB Compliance NO CE Compliance Base on different order YES Unit Remark 5. Power consumtion Max 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. CB Compliance 5. Video NO. Item Min
Typ Max 1. Linearity Distortion,Verticl 1 ％ 2. Linearity Distortion,Horizontal 1 ％ 3. Trapezoidal Distortion,Verticl 1 ％ 4. Trapezoidal Distortion, Horizontal 1 ％ 5. Over scan, Verticl 93 95 97 ％ 6. Over scan, Horizontal 93 95 97 ％ 7. Brightness Maximum 280 8. Video Noise Limited Sensitivity(@S/N=30dB) VHF dBuV 51 Technical Specification 9. Video Noise Limited Sensitivity(@S/N=30dB) UHF 54 dBuV 10. Selectivity ‐1.5M 35 dB 11. Selectivity +8M 40 dB 12. Tuning Range ‐0.7 MHz 13. Resolution Horizontal 1920 Lines 14. Resolution Vertical 1080 Lines 6. Chroma NO. Item Min Typ Max Unit Remark 1. White Balance, X axis 2. White Balance,Y axis 3. White Balance,Color Temperature 6500 9800 12500
kdeg 12500(266,276) 9800(280,290) 6500(313,329) 4. Color Sensitivity 30 dB 5. Color Burst Lock‐in Range +/‐300
Hz 6. Color Killer Sensitivity 30 dBuV NO. Item Min
Typ Max Unit Remark 1. Audio Noise Limited Sensitivity,VHF‐L
25 dBuV 2. Audio Noise Limited Sensitivity,VHF‐H
25 dBuV 3. Audio Noise Limited Sensitivity,UHF 28 dBuV 4. Buzz(S/N Ratio) 40 dB 5. Distortion 3 ％ 6. Audio ouput,L/R,at 10％ THD 6 W 7. Audio ouput,Center 6 W 8. Stereo Separation 21 dB 9. Speaker Impedance 8 ohm 10. Speaker Power rating 8 W Item DC Voltage, Audio DC Voltage, Tuner Min
Typ 12 3.3 Max Unit V V Remark 7. Audio 8. Power NO. 1. 2. Technical Specification 9. External Interface NO. Item Min
Typ Max Unit Remark 1. Video Input Level 1 Vpp 75 ohm 2. Video Input Frequency Response 4.5 MHz 3. Video Input S/N 40 dB 4. Audio Input Level 0.5 Vrms 5. Audio Input Frequency Response 15 kHz 6. Audio Input S/N 40 dB 7. Audio Input Distortion 3 ％ 8. Audio Input Dynamic Range 2 V 9. Video output Level 1 Vpp 10. Video ouput Frequency Response 4.2 MHz 11. Video output S/N 50 dB 12. Audio output Level 0.5 Vrms 13. Audio output Frequency Response 80 12000
Hz 14. Audio output S/N 50 dB 15. Audio output Distortion 6 ％ 0.7 VPP
0.7 VPP
16. Video Input Level,R/G/B 17. Video Input Level,Component(Y,Pb,Pr) 18. RGB Input Resolution,Vertical 1080 pixel
19. RGB Input Resolution,Horizontal
1920 pixel
20. RGB Input Horizontal Frequency
68 kHz
21. RGB Input Frame Rate 60 Hz
10. The Others NO. Item Min
Typ Max Unit Remark 1. Search sensitivity 40 dBuV 2. Clock,real time gain or loss(sec per day) NO sec 3. Software Funcitonality Test YES 4. REMOCON Working sensitivity,Straight 8 m 5. REMOCON Working sensitivity,T/B/L/R 6 m 6. Close caption sensitivity 46 dBuV 7. Teletext sensitivity 46 dBm 8. Resonance of unit(sweep freq:50~1000) NO Technical Specification 11. Customer Menu Setup(as shipped condition) NO. Item Specification Remark 1. PSM Standard 2. SSM Standard 3. Volum 20 4. Mute off 5. Input Mode RF 6. Customer menu language 7. AVL off 8. Sleep Timer off 9. Auto sleep off 10. Blue back NO 11. Surround off 12. Caption off 13. Noise Reducer Middle Traditional Chinese Base on different order 12. Reliability NO. Item Min
Typ Max Unit Remark 1. ESD 4 kV IEC‐1000‐4‐2 2. EFT/Burst kV IEC‐1000‐4‐4 3. Surge Immunity kV IEC‐1000‐4‐5 4. Voltage Dip Test,10ms ％ IEC‐1000‐4‐11 5. Voltage Dip Test,100ms ％ IEC‐1000‐4‐11 6. Operation Temperature deg 7. Operation Humidity ％ 8. Storage Temperature deg 9. MTBF(confidence Level:90%) hour Technical Specification DTV‐Productions Specification Model # 39” Country( West Eu./East Eu./Russia/AP/US/S.A./Japan/…) West Eu Brand Category (Monitor/TV/Combo/Portable TV…) Panel technology (LCD / PDP) Market Position (High/Mid/Access,,,) Cabinet Design (Example: 01,23 series ) Product Nb Chassis solution Chassis name Chassis PCB Standard Predecessor (replace) MP date requested (ETD) MP date confirmed by supplier (ETD/ETA) Status( Pre./Finish ) Regional requirement Homologation (Gostandard/CE/MPTT/CB/…) RoHS Power supply(100‐240V AC +/‐10%/...) Power consumption working / Annual Power consumption standby Power plug(VDE/UL/BS/…) Picture display Screen size : diagonale (inch) Aspect ratio (16/9 // 4/3 // 15/9) 1st panel supplier : panel suppliers 1st panel supplier : panel reference Panel Display Type(MVA/PVA/IPS/…) 1st panel supplier : resolution Dynamic contrast ratio Video signal process Comb Filter (2D/3D) Noise Reduction (adaptative/3D/…) Picture improvement ( LTI/CTI,BLE,WLE,...) ODM/Skyworth TV D‐LED Class 39E36 ‐ MSD6306PUN 6M62E Skyworth RGB New Standard ‐ 2013.9 ‐ ‐ VDE Yes 100‐240V AC (‐20%,+10%) ‐ <1W VDE/2pins 39 16:9 Skyworth Skyworth TFT LCD 39”1920X1080 >10000:1 3D 3D LTI/CTI Technical Specification Color process (Gama correction/Skin correction /... ) Colour preset (Cool/Neutral/Warm) Picture control ( Bright/Con./Sharpness/Color/Tint/…) Picture presets : Normal/Bright/Soft/Personal Picture freeze Multi picture : PIP ( AV )/POPAV Dynamic Backlight Control LED Backlight Deinterlacer (No/linerar/motion adaptive/motioncompensative) Film mode / reverse 3:2/2:2 pull down Full HD support ( 1080P ) Single scan / Dual scan ( 120HZ ) Zoom type : 4/3 format Zoom type : 14/9 Zoom Zoom type : 16/9 Zoom Zoom type : 16/9 Zoom up/down Zoom type : Cinerama Zoom type : 16/9 Format Zoom type : Auto ( by SCART Pin8 and WSS ) Picture Auto adjustment (PC mode) 3D Panel Type(PR / SG) 3D Mode 3D To 2D (Y/N) 2D To 3D (Y/N) Left / Right Swap (For PR Panel) Sound Sound type ( Mono/AV stereo/Stereo ) Music Power (Watt)/RMS Power (Watt) Tone control ( Bass&Treble / Graphic Equalizer ) Special sound effect ( AVL / WIDE / Pseudo /… ) Suround system ( Dolby / VD / SRS / BBE / … ) Follow main IC Cool/Neutral/Warm Yes Normal/Bright/Soft/Personal Yes NO NO D‐LED 3D motion adaptive Yes / Yes Yes Single scan YES NO YES YES YES YES YES YES NO NO NO NO NO stereo 39”:2X6W Bass&Treble AVL Built‐in Surround Technical Specification Sound control ( Volume , Balance , Mute )
Sound presets (Personal/Music/Film/News/Standard) Headphone volume control ( Separated / linked ) Sound quality ( High / Mid / Low ) Reception and Decoding capability RF rangeATV RF rangeDTV Color System (PAL/SECAM/NTSC/PAL M,N ) Audio Standard ( B/G/H/D/K/K'/I/L/L' ) Stereo audio system ( Nicam,MTS,A2,….) Video standard NTSC 3.58 / 4.43 (AV)/PAL 60 DTV SD support (DVB‐T/S/C , ATSC , QAM , … ) DTV HD Support MHEG5 HD capability with YPbPr PC capability (up to maximum format) HDMI capability AV/PC Format) Compatible video format if DVD/USB: DviX/VCD/SVCD/JPEG/AVI/MPEG2/WMV‐ HD/SD Compatible audio format if DVD/USB:MP3/WMA/AAC/MPEG1/… Playable Discs (CD/CD‐R(RW)/CD‐ROM/DVD+R/+RW/‐R/‐RW)
Card reader format compatibility Macrovision PVR Network User convenience OSD Language* OSD Positioning OSD Transparency Adjust OSD Timeout Adjust Customer Brand name(LOGO) Volume, Balance, Mute Personal/Music/Film/News/Standard Yes(Linked) 45MHz～866MHz VHF 177‐213 MHZ, UHF 473‐803 MHZ PAL/SECAM/NTSC DK/I/BG/M PAL/SECAM/NTSC DK/I/BG/M Nicam ,A2 NTSC 3.58/4.43 , PAL DVB‐T MPEG2,MPEG4,H.264 NO Yes (720p; 1080i; 1080p@24/50/60Hz; 480i/p; 576i/p) 39”:1920X1080Hz 60Hz Up to 1080P 24/50/60HZ JPEG/MPEG2/MPEG4/H.264/DivX (depending on license) MP3/WMA(depending on license) NO NO Yes Yes NO English/TBD No No No Yes Technical Specification IB languages ATV Program Numbers (example: 99+3AV input ) DTV Program Numbers Program edit ( naming , sorting , skip , swap …. ) Auto Naming/Auto Sorting TV Guide(DTV EPG) Favorite program Number of buttons on cabinet (Power; Vol+/‐; Pr+/‐,Menu ) Main switch button (yes/No) CCD(Closed Caption)/V‐CHIP Text Standard: (Top, FLOF,,,) Teletext Level: 2.5 / 1.5 Pages for teletext Teletext character sets **** DVB‐T teletext Real clock Sleep timer Timer Parent Control ‐Source and Channel lock (Input code forcertain channel) Parent Control ‐ Child lock (set the lock of the keyboard,only the RCU can control the TV)
Parent Control ‐ Kid pass (preset the ontime, channel foreach day of the week) Parent Control ‐ Channel lock (For digital transmissionand DVD program, to filter some programms) Calendar / Games No program auto switch off Hotel mode (Y/N) DVD player (No/slot/tray) Tuner FM (yes/No) software download(RS232/CI/USB/OAD) Factory reset Screen saver English 100+7AV 200 Naming / Skip / Swap No EPG(next Seven‐day) Yes Vol+/‐; Pr+/‐, Menu ,Source,Power No No /No No Yes Yes Yes Yes From DTV 10‐240 Min Turn On / Off, Program Switch Yes Yes No Yes No Yes Yes No No USB Yes(in factory menu,reset the setting to shipment state ) Yes Technical Specification Blue Back LED indicator(Power on/Standby) Connectors ‐Rear RF Input (Antenna): Air/ Cable/ 2in1 Scart : CVBS in&out / RGB / S‐VIDEO CINCH video in / outAV1 CINCH audio in / out (No volumpe control on Audioout/can be jack 3,5mm) S‐video in Component Video Input (YCrCb/YPrPb) Component Audio Input (YCrCb/YPrPb) VGA in / Audio L/R in / Jack audio in 3.5mm HDMI DVI Audio input for DVI CINCH subwoofer out / Coaxial out (S/PDIF) Headphone output connector (mm) RS232 ( Y/N , VGA or DB9 port …) Card Readers USB slot (No/1.1/2.0) DVB‐CI (common interface) External power converter input Connectors ‐Side HDMI AV‐IN AV‐OUT Component Video Input (YCrCb/YPrPb) Component Audio Input (YCrCb/YPrPb) Headphone output connector (dia.mm) CINCH subwoofer out / Coaxial out (S/PDIF) USB slot (No/1.1/2) DVB‐CI (common interface) DLNA RF Input (Antenna): Air/ Cable/ 2in1 VGA in / Audio L/R in / Jack audio in 3.5mm Yes Blue / Red Antenna No 1/ 0 1/1 No 1 1 VGA + dia. 3.5mm for audio 2 No No No 1 No No 2 No No 1 1 NO 1 1 1 NO 1 NO NO Antenna VGA + dia. 3.5mm for audio in Technical Specification UI/RC UI design (font/pixel, 2D/3D graphic engine..) RC Model RC system RC # of keys Accessories included Carton IB Circuit diagram Batteries Product registration Card AC Cable Length Audio Cord (Jack 3.5mm) VGA Cord Wallmount frame Antenna Cable 6 in 1( YPbPr & CVBS) cable adapter 3D Glasses General Data Size (W x H x D, with stand) in mm Size (W x H x D, without stand) in mm Package Size (W x H x D, without stand) in mm Net Weight in kg Gross Weight in Kg Design / Mechanical Wallmount VESA compatible (standard reference) Adaptor for VESA wallmount compatibility Desktop Stand (included/optionnal + ref/No) Panel Tilt (Fowards/Backwards/Rotation)
Swivel function desktop stand (yes/No) + motorized? Docking station (yes/No) Floor Stand (included/optionnal + ref/No)
Glass shield (yes/No) Finish on Front SOD Standard Commend RCU RGB Standard Traditional Chinese Traditional Chinese No No Yes(Traditional Chinese) 1.8m No No Optional No No YES(If have 3D mode) Yes Yes included No No No No No ‐ Technical Specification Finish on side Finish on back Finish on stand number of colors on carton box Brand logo Other logo External AC/DC Power with DC power cord (yes/No) Handle (yes/No) Detachable speaker (yes/No) Rating Label langages ‐ ‐ ‐ Customer Inlet No No No No English 机型 认证标
NO 名称 位号 生产厂家 厂家型号 规格 1 接收头 IR1 海格科技 SDR138 5300‐147438‐0S00 2 扬声器 SPEAKER 中山声力 SL411‐01F 5631‐108104‐0180 3 晶振 Y1/Y2 陕西壹加壹
HC‐49U/S 4900‐124053‐R000 4 高频头 U10 Silicon lab SI2157 471J‐SI2150‐0280 所有 5 IC 记 U6 芯智 MSD6306PUN 475C‐M63061‐1280 U7 CFEON EN25Q32B 471R‐N25323‐0080 U1 唯隆 AOZ3015PI 4786‐A30151‐0080 U12 新晔电子 TPA3113 4722‐T31130‐0280 U13 帕太 BH3544F‐E2 4740‐B35440‐0080
U5/U11 A1 半导体 AS1117L‐3.3/TR‐HF 47B6‐A11170‐03
U4 A1 半导体 AS1117L‐3.3/ADJ 47B6‐A11174‐0300
U3 亿思达国际
MP1470GJ‐Z 476A‐M14700‐0060 QA1 沛裕电子 AP2181DWG‐7 47C5‐A21810‐0050 P/N(参考) IC Block Diagram 1. AOZ3015PI 2. ME9435A 3. ME4953 4. MSD6306PUN SPI FLASH 32M bit HDMI input YUV input VGA input HDMI1
YUV VGA CVBS1 MSD6306PUN CVBS input 音频 input L/R L/R L/R1 L/R2 TUNER RF EAR OUTPUT CVBS USB input IF AMP TDA3113 USB CONNECTOR LVDS CONNECTOR 5. EN25Q64‐104HIP 6. TPA3113 7 BH3544F‐E2
8 TDST‐G070D
Main PCB Top 6M62E
Factory Adjust Menu
(V0.0)
1. Description
Enter factory mode：
Open source menu，and then press digital button “3”, “1”, “9” , “5”
in
turns to enter the factory menu. Press ↑ and ↓ button to choose the
item, press OK button enter the submenu, press MENU to ruturn to
upper menu , press ← and → button to adjust the value,
Leave factory mode:
Press menu button to back to upper menu until leave factory mode。
Software information:
Enter factory mode, you can get the software information from the
bottom of the menu.
Panel information:
Enter factory mode, enter “Panel SETTING” item, you can get the
panel information from the bottom of this menu.
Aging mode:
You can press the shortcut key in the factory remote control to open
or close the aging mode.
ADC adjusts:
YPBPR source ADC:
Switch to YPBPR source, input 100% color bar pattern, enter
factory, select “AUTO ADC” item in the “ADC CALIBRATION”
menu, press → button to begin auto adjust. When it is finish, it will
show “OK” or “FAILE”. If “FAILE” is showed, you need to try
again.
NOTE: YPBPR ADC need to do twice by use 576P and 720P
signal separate.
VGA source ADC:
Switch to PC source, input tessellated white and black signal,
enter factory, select “AUTO ADC” item in the “ADC CALIBRATION”
menu, press → button to begin auto adjust. When it is finish, it will
show “OK” or “FAILE”. If “FAILE” is showed, you need to try again.
White balance:
Enter factory mode, enter “W/B ADJUST” item, you can adjust white
balance in this menu.
Over scanning:
Enter factory mode, enter “Panel SETTING” submenu, enter
“OVERSCAN” submenu, you can adjust the over scan in these menu.
OutFactory reset:
Enter factory mode, enter “SYSTEM SETTING” item, select “OUT
FACTORY SET” item and press OK button to reset the flash memory.
TV set will restart when it is finish.
INIT EEPROM：
Enter factory mode, enter “SYSTEM SETTING” item, select “FAC
RESET DEFAULT” item and press OK button to reset the EEPROM.
TV set will restart when it is finish.
Update software (by USB):
Copy the new software (name by “MERGE.bin”) to the root directory
of USB drive. Plug the drive to the USB2 socket (if there are two USB
socket, make sure you use the socket 2). Enter factory, select “Software
Update (USB)” item and press OK button to begin update. TV set will
restart when finish. Note, you need to restart the TV set again by AC
power.
We suggest you need to do “INIT EEPROM” and “Factory reset”
after software update
5
4
Connetor
3
2
1
Inverter controller
5V Standby Power(option) 3A
D
D
+5V_Standby
BL-ON/OFF
BL-ADJUST
+5V_Normal
FB1
FB2
U1
AOZ3015PI/SOP8
+5V_Normal
0R/1206/5%
+5V_Standby
2
VIN
R1 100K/0402/5%7
+12V_PWR
6
R3 27K/0402/5%/NC
C2
C4
C3 0.1uF/0402/16V
10uF/16V/0805
10uF/16V/0805
CON14/PIN=2.5MM
4
C5
1nF/0402/16V/NC
LX
EN
Vo
COMP
FB
VCC
R7
C6
20K/0402/5% 0.1uF/0402/16V
PGND
9
L7
0R/1206/5%
22uH_3A
D5
1N4148
8
1
R1
R5
C7
BL-ON/OFF
+
CA3
C1
0.1uF/0402/16V/NC
0.1uF/0402/16V
470uF/16V/EC3.5
R10
R2
FB6
0R/1206/5%/NC
C
2
VDDC
U3
MP1470
0R/1206/5%
0R/1206/5%
+12V_NORMAL
3
20R/0402/5%
2
STANDBY R19
200R/0402/5%
C17
10uF/16V/0805
PWR-ON/OFF
NOTICE:
FB
R18
4.7K/0402/1%
R2
0.1uF/0402/16V
10uF/16V/0805
C13 C19 C14 C15 C16
10uF/16V/0805
10uF/16V/0805
10uF/16V/0805
R20
R22
10K/0402/1% or 8.2K/0402/1%
B
Resistors close to the DC-DC
If chip is 3393,The R2 Value is 10K 1%
If chip is 6306,The R2 Value is 8.2K 1%
H9
1
H4
1
H3
9
5
9
5
9
5
9
5
4
8
4
8
4
8
4
8
4
3
7
3
7
3
7
3
7
3
2
6
2
6
2
6
2
6
2
NC
+5V_Standby
GND
4
9
8
7
3
2
1
3
2
H2
1
H1
AMS1117-3.3
1
4
U5
R1
1
R25
470R/0402/5%
Test Point & MARK
IN
OUT
ADJ
IN
1
L2
22uH_3A
Vout=0.8V*(1+R1/R2)
1
2
4
3.3V Power
+1.8V_DDR2
2.2uF/0603/16V
2.2uF/0603/16V
0.1uF/0402/16V
2
SW
100K/0402/5%
C21
10pF/0402/16V
H :Power on
L :Power off
+3.3V_Normal +3.3V_Standby
0.1uF/0402/16V
C23 C24 C25
C18
10uF/16V/0805
C20
U4
OUT
ADJ
R2
C12
1uF/0402/16V
EN
4.7K/0402/5%
Q4
3904/SOT-23
AMS1117-Adj
BST
增加100UF电解电容，删除C15/C16,改善纹波
R14
R17
10K/0402/5%
R16
0.1uF/0402/16V
R23
100K/0402/5%
3
1
R24
22K/0402/5%
IN
6
+3.3V_Standby
5
+5V_Normal C22
C
FB8
+5V_Normal
5
1.5V/1.8V Power_Normal
R1
BRI_ADJ
+12V_PWR +5V_Standby
FB9
3
C9
0.1uF/0402/16V/NC
U2
4953/SOP8
1
8
S1
D1 7
2
D1 6
3 G1
R12
C10
D2 5
4 S2
100K/0402/5%
G2
D2
0.1uF/0402/16V
R13
C11
100K/0402/5%
1
R15
Q3
0.1uF/0402/16V/NC
22K/0402/5%
3904/SOT-23
If POWER BOARD IS 5stb ONLY ,PL NOT PATCH THESE GUY.
220R/0402/5%/470R/0402/5%
R26
R199
4.7K/0402/5%
Max :1.0A
R21
100K/0402/5%
STANDBY
1
3904/SOT-23
1.15V Core Power
Standby controller
STANDBY
STANDBY
VBL_CTRL
Q2
Vout=0.8V*(1+R1/R2)
+12V_PWR
B
Q1
1
R9
3904/SOT-23 10K/0402/5%
R159
R11
10K/0402/5% BL-ADJUST
22K/0402/5%
C104
C85
9.1K/0402/1%
+5V_Standby
STANDBY
R8
100R/0402/5%
1nF/0402/16V R193
10K/0402/5%/NC
0.1uF/0402/16V/NC
+12V_NORMAL
Power Switch
STANDBY
R6
10K/0402/5%/NC
51K/0402/1%
C8
2.2nF/0402/16V
+12V_PWR
R4
R200
4.7K/0402/5%
200R/0402/5%
5
3
+12V_PWR
2
STANDBY
AGND
FB5
0R/1206/5%/NC
3
FB7 0R/0402/5%/NC
解决耳机冲击声
MUTE_EAR
3
1
2
3
4
5
6
7
8
9
10
11
12
13
14
MUTE_EAR
CN1
C26 C27
C28
2.2uF/0603/16V
0.1uF/0402/16V
NC
NC
NC
6
NC
C29
0.1uF/0402/16V
2.2uF/0603/16V
输入加大滤波电容解决插入个别硬盘重启
H5
NC
H6
NC
1
A
1
1
R27
100R/0402/5%
A
H7
NC
Vout=1.25V*(R1+R2)/R1
If chip is 3393,The R1 Value is 220R 5% Vout=1.8V
If chip is 6306,The R1 Value is 470R 5% Vout=1.5V
NOTICE:
Title
Size
Custom
Date:
5
4
3
2
MSD3393
Document Number
Rev
1.0
System power
Sunday, July 14, 2013
1
Sheet
1
of
9
5
4
HDMI0-RX0P
HDMI0-RX0N
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX2P
HDMI0-RX2N
HDMI0-CLKN
HDMI0-CLKP
HDMI0-SCL
HDMI0-SDA
HDMI0-HPDIN
HDMI2-RX0P
HDMI2-RX0N
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX2P
HDMI2-RX2N
HDMI2-CLKN
HDMI2-CLKP
HDMI2-SCL
HDMI2-SDA
HDMI2-HPDIN
MHL_CABLE-DET
HDMI2-RX0P
HDMI2-RX0N
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX2P
HDMI2-RX2N
HDMI2-CLKN
HDMI2-CLKP
HDMI2-SCL
HDMI2-SDA
HDMI2-HPDIN
MHL_CABLE-DET
+3.3V_Norm al
HDMI1-CLKN
HDMI1-CLKP
HDMI1-RX0N
HDMI1-RX0P
HDMI1-RX1N
HDMI1-RX1P
HDMI1-RX2N
HDMI1-RX2P
VGA_HSYNC
RGB0_B+
RGB0_G+
RGB0_GRGB0_R+
VGA_VSYNC
HDMI-ARC
HDMI-CEC
HDMI-ARC
HDMI-CEC
PC & YPBPR Interface
VGA-Rin
VGA-Gin
VGA-Bin
+3.3V_Norm al
RGB1_B+
RGB1_SOG
RGB1_G+
RGB1_GRGB1_R+
RGB0_R+
RGB0_GRGB0_G+
RGB0_B+
R28 33R/0402/5% C48
R29 68R/0402/5% C49
R30 33R/0402/5% C50
R31 33R/0402/5% C51
47nF/0402/16V
47nF/0402/16V
47nF/0402/16V
47nF/0402/16V
R32 33R/0402/5% C52
R33 68R/0402/5% C53
R34 33R/0402/5% C54
R35 33R/0402/5% C55
R36 0R/0402/5% C56
47nF/0402/16V RGB1_R+
47nF/0402/16V RGB1_G47nF/0402/16V RGB1_G+
47nF/0402/16V RGB1_B+
1nF/0402/16V RGB1_SOG
VGA_HSYNC
VGA_VSYNC
VGA_HSYNC
VGA_VSYNC
YPbPr_PR
YPbPr_Y
YPbPr_PB
CVBS0+
CVBS_VCOM
CVBS1_OUT
VDDC
+3.3V_AU
LINEIN_R1
LINEIN_L1
AU_VAG
AU_VRM
CVBS IN & OUT
AV1
R38 150R/0402/5% C58
47nF/0402/16V
CVBS0+
R39 180R/0402/5% C60
47nF/0402/16V
CVBS_VCOM
CVBS1_OUT
CVBS1_OUT
MSD3393LU
VDDC
AVDD5V_MHL
HDMI2-HPDIN
HDMI2-SCL
HDMI2-SDA
MHL_CABLE-DET
HDMI1-SDA
HDMI1-SCL
HDMI0-SDA
HDMI0-SCL
+1.8V_DDR2
VDDC
ARC_DET
HDMI2-RX0P
HDMI2-RX0N
HDMI2-CLKP
HDMI2-CLKN
HDMI0-RX2P
HDMI0-RX2N
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX0P
HDMI0-RX0N
HDMI0-CLKP
HDMI0-CLKN
MSD3393LU
C32
C33
0.1uF/0402/16V
0.1uF/0402/16V
+3.3V_Norm al
KEY1-SAR1
KEY0-SAR0
+3.3V_Norm al
USB1_D+
USB1_DUSB2_D+
USB2_DSys tem -RST
PANEL_ON/OFF
IR-in
HDMI-CEC
UART-RX
UART-TX
HDMI-ARC
SPI_SCK
SPI_CSN
SPI_SDI
SPI_SDO
BRI_ADJ
VBL_CTRL
HDMI1-HPDIN
HDMI0-HPDIN
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
+3.3V_Norm al
G7_RXO3G6_RXO3+
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
2.2uF/0603/16V
2.2uF/0603/16V
LINEIN_L4
LINEIN_R4
+3.3V_Norm al
C36
2.2uF/0603/16V
+3.3V_PLL
L4
0R/0603/5%
C35
0R/0603/5%
C38
0.1uF/0402/16V
C37
0.1uF/0402/16V
0.1uF/0402/16V
C39
0.1uF/0402/16V
3.3V
+3.3V_ADC
+3.3V_Norm al
D
L5
C40
2.2uF/0603/16V
0R/0603/5%
0.1uF/0402/16V
0.1uF/0402/16V
C46
C41
C42
C43
C44
C45
0.1uF/0402/16V
0.1uF/0402/16V
0.1uF/0402/16V 2.2uF/0603/16V
C47
0.1uF/0402/16V
Audio Line Out
LINE0OUT_L
HEAT
AV_AUOUTL1
C165
SINK
R37
200K/0402/5%
1nF/0402/16V
LINE0OUT_R
AV_AUOUTR1
C57
R40
200K/0402/5%
H8
1nF/0402/16V
1
2
LINEOUT_APML
C62
TUNER_SDA
TUNER_SCL
MHL_VBUS-EN
AMP-MUTE
PWR-ON/OFF
SPDIF_OUT
B2_RXE3+
B3_RXE3B4_RXEC+
B5_RXEC-
C64
C65
XTALI
XTALO
AV1-Lin
AV1-Rin
LINEIN_L4
LINEIN_R4
LINE3OUT_L
LINE3OUT_R
LINE0OUT_L
LINE0OUT_R
IFAGC
VIFP
VIFM
LINEIN_L1
LINEIN_R1
3.3V MPLL
+3.3V_AU
L3
102
101
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
VDDC
2.2uF/0603/16V
2.2uF/0603/16V
+1.8V_DDR2
+3.3V_Normal
C61
C63
C34
0.1uF/0402/16V
3.3V audio
+1.8V_DDR2
SAR1
SAR0
AVDD_MOD
DP_P1
DM_P1
DP_P0
DM_P0
RESET
INT/GPIO64
IRIN
CEC
TEST
DDCA_CK
DDCA_DA
ARC
SPI_CK
SPI_CZ
SPI_DI
SPI_DO
PWM0
PWM1
HOTPLUG_A
HOTPLUG_C/D
LDE/LVB0M
LCK/LVB0P
LVB1M
LVB1P
LVB2M
LVB2P
AVDD_MOD
LVB3M
LVB3P
LVA0M
LVA0P
LVA1M
LVA1P
LVA2M
LVA2P
LINE3OUT_L
VGA-Lin_AU
VGA-Rin_AU
+3.3V_PLL
+3.3V_ADC
AV1-Lin
AV1-Rin
1
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
RX1N_B
RX1P_B
RX2N_B
RX2P_B
AVDD_MOD
RXCN_A
RXCP_A
RX0N_A
RX0P_A
RX1N_A
RX1P_A
RX2N_A
RX2P_A
HSYNC0
BIN0P
GIN0P
GIN0M
RIN0P
VSYNC0
AVDD3P3_ADC
BIN1P
SOGIN1
GIN1P
GIN1M
RIN1P
VSYNC1
CVBS1
CVBS0
VCOM
CVBS_OUT1
VDDC
AVDD_AU33
AUR0
AUL0
AUR1
AUL1
VAG
VRM
AUDIO IN
VGA-Lin_AU
VGA-Rin_AU
C31
0.1uF/0402/16V
DDR2 1.8V
E-PAD
Test
MARK
MARK
RX0P_B
RX0N_B
RXCP_B
RXCN_B
RX2P_D
RX2N_D
RX1P_D
RX1N_D
RX0P_D
RX0N_D
RXCP_D
RXCN_D
VDDC/AVDDL_DVI
GND_EFUSE
AVDD_5V
HOTPLUG_B
DDCDB_CL
DDCDB_DA
MHL_DET
DDCDA_DA
DDCDA_CL
DDCDC_DA
DDCDC_CL
VDDIO_DATA
VDDC/DVDD_DDR_DATA
SAR2
U6
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
HDMI2-RX1N
HDMI2-RX1P
HDMI2-RX2N
HDMI2-RX2P
C30
2.2uF/0603/16V
AUL4
AUR4
AUOUTL3
AUOUTR3
AUOUTL0
AUOUTR0
IFAGC
VIFP
VIFM
AVDD3P3_DADC
AVDD3P3_DMPLL
XIN
Xout
AVDD_MOD
VDDIO_CMD
VDDC/DVDD_DDR_CMD
GPIO0/GPIO44
GPIO1/GPIO45
GPIO2/GPIO46
GPIO3/GPIO47
GPIO4/GPIO48
GPIO5/GPIO49
LVA3P
LVA3M
LVACKP
LVACKM
D
1
HDMI1-RX0P
HDMI1-RX0N
HDMI1-RX1P
HDMI1-RX1N
HDMI1-RX2P
HDMI1-RX2N
HDMI1-CLKN
HDMI1-CLKP
HDMI1-SCL
HDMI1-SDA
HDMI1-HPDIN
HDMI1-RX0P
HDMI1-RX0N
HDMI1-RX1P
HDMI1-RX1N
HDMI1-RX2P
HDMI1-RX2N
HDMI1-CLKN
HDMI1-CLKP
HDMI1-SCL
HDMI1-SDA
HDMI1-HPDIN
2
VDDC
TP4
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
HDMI0-RX0P
HDMI0-RX0N
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX2P
HDMI0-RX2N
HDMI0-CLKN
HDMI0-CLKP
HDMI0-SCL
HDMI0-SDA
HDMI0-HPDIN
3
VDDC 1.15V
HDMI Interface
R41
200K/0402/5%
CON2/NC
1nF/0402/16V
LINE3OUT_R
LINEOUT_APMR
C66
R42
200K/0402/5%
1nF/0402/16V
DIF IN
Close to Mstar IC
C67 VIFP
IFP
0.1uF/0402/16V
C68 VIFM
IFN
0.1uF/0402/16V
USB & SPDIF_OUT
+3.3V_TU
+3.3V_Standby
Close to Mstar IC
1
2
3
R50
1
10K/0402/5%
C
C78
2.2uF/0603/16V
C75
2.2uF/0603/16V
Q5
3906/SOT-23
R52
1K/0402/5%
XTAL
XTALO
CHIP_CONFIG
R51
0R/0402/5%
Sys tem -RST
R54
C77
100K/0402/5% 1nF/0402/16V
XTALI
C76
33pF/0402/16V
{IPAD_PWM1, PAD_PWM0}
B51_NO_EJ 4'h00
Y1
3
R53
1M/0402/5%
24.000MHz
C79
33pF/0402/16V
PWM1
R57
4.7K/0402/5%
PWM0
R58
4.7K/0402/5%
TUNER_SCL
TUNER_SDA
TUNER_SCL
TUNER_SDA
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G7_RXO3G6_RXO3+
FLASH
DEBUG
+5V_Standby
+3.3V_Standby
+3.3V_Standby
U7
MX25L3205
MUST pull high to 5VSTB
R64 R65
ISP AND VGA EDID
SPI_SCK
SPI_SDI
UART-TX R66
UART-RX R67
4.7K/0402/5%
4.7K/0402/5%
100R/0402/5%
UART_TX
100R/0402/5%
UART_RX
C81
8
7
6
5
VDD
HOLD#
SCK
SI
CE#
SO
WP#
VSS
1
2
3
4
SPI_CSN
SPI_SDO
#F_WP
R63
10K/0402/5%
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
0.1uF/0402/16V
R48
1K/0402/5%
C73
D51
ESD/NC
IR_in
LED_R
KEY1-SAR1
D52
ESD/NC
0.1uF/0402/16V
LED_G
+3.3V_Norm al
+3.3V_Standby
+3.3V_Standby
R55
R56
4.7K/0402/5%
LED_G
2K/0402/5%
+5V_Standby
Q6
Q7
G7_RXO3G6_RXO3+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
KEY1-in
C
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
KEY0-in
2
PWR-ON/OFF
BRI_ADJ
VBL_CTRL
MHL_VBUS-EN
AMP-MUTE
PANEL_ON/OFF
ARC_DET
R45
8.2K/0402/5%
8.2K/0402/5%
R47
KEY0-SAR0
1K/0402/5%
C74
KEY0-in
KEY1-in
1
22nF/0402/16V
1
2
3
4
5
6
7
8
9
10
11
12
PWR-ON/OFF
PWM0
PWM1
MHL_VBUS-EN
AMP-MUTE
PANEL_ON/OFF
ARC_DET
R60
10K/0402/5%
STANDBY
D54
ESD/NC
IR_in
R62
100R/0402/5%
C80
33pF/0402/16V
IR-in
R61
4.7K/0402/5%
3
D1
BAV99
R49
100K/0402/5%
+5V_Standby
CN3
CON20W-J20-12
KEY1-SAR1
1
LED_R R59
4.7K/0402/5%
1
2
IFAGC-T
0R/0402/5% C72
2
0R/0603/5%
R46
3
+5V_Standby
+3.3V_Standby
R44
KEY0-SAR0
1
IFAGC
RESET
IR-in
3
R43
10K/0402/5%
3904/SOT-23
2
C71
2
C70
3904/SOT-23
1
C69
2.2uF/0603/16V
0.1uF/0402/16V
2.2uF/0603/16V
L6
2
SPDIF_OUT
D53
ESD/NC
1
USB1_DUSB1_D+
USB1_DUSB1_D+
IR&KEYB
AU_VRM
AU_VAG
USB2_DUSB2_D+
USB2_DUSB2_D+
SPDIF_OUT
Standby :H :Power on Green Led
L :Power off Red Led
0.1uF/0402/16V
B
B
A
A
Title
Size
E
Date:
5
4
3
2
1
MSD3393
Docum ent Num ber
Rev
1.0
MAIN CHIP
Saturday, June 08, 2013
Sheet
2
of
9
5
4
3
2
1
LVDS CONNECTOR ( 1 DIP + 2 SMT OPTIONAL )
HI CONNECTOR
Power for panel
D
D
VCC-Panel
FB3
0R/1206/5%/NC
+5V_Normal
TUNER_SDA
M_SDA
0.1uF/0402/16V1
3
5
7
9
11
B2_RXE3+
13
B4_RXEC+
15
B6_RXE2+
17
G0_RXE1+
19
G2_RXE0+
21
23
25
DCR-IN
27
29
31
G6_RXO3+
33
R0_RXOC+
35
R2_RXO2+
37
R4_RXO1+
39
R6_RXO0+
41
43
45
R481 NC/100R/0402/5%
FB4
VCC VCC
VCC VCC
GND GND
GND GND
A4P A4M
A3P A3M
ACKPACKM
A2P A2M
A1P A1M
A0P A0M
GND GND
IO MODE
PWMDCRO
GND GND
B4P B4M
B3P B3M
BCKPBCKM
B2P B2M
B1P B1M
B0P B0M
GND GND
SDA SCL
GND GND
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
VPANEL_IN
VCC-Panel
CN2
U8
0R/1206/5%
+12V_NORMAL
C82
R68
0.1uF/0402/16V/NC
100K/0402/5%
+3.3V_Normal
B3_RXE3B5_RXECB7_RXE2G1_RXE1G3_RXE0SG_SYNC
8_10BIT_SEL
DCR-OUT
R73
10K/0402/5%NC
3
100uF/16V
C
C103
+
PANEL_ON/OFF
R70
0/NC
G7_RXO3R1_RXOCR3_RXO2R5_RXO1R7_RXO0-
R72
NC/0
PANEL_ON/OFF
S
S
S
G
9435/SOP8
5
D 6
D 7
D 8
D
Q8
AO3401A/SOT-23/NC
1uF/0402/16V/NC
C84
0.1uF/0402/16V/NC
R69
100K/0402/5%
Q9
1
R71
4.7K/0402/5%
R2
4.7K/0402/5%
3904/SOT-23
C
Net to other page
G3_RXE0-
M_SCL TUNER_SCL
R488 NC/100R/0402/5%
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G7_RXO3G6_RXO3+
NC/CON22X2_2.0
R74
DCR-OUT
100R/0402/5%/NC
BRI_ADJ
C83
1
2
3
4
2
CA6
R75
DCR-IN
100R/0402/5%/NC
R7_RXO0R6_RXO0+
R5_RXO1R4_RXO1+
R3_RXO2R2_RXO2+
G7_RXO3G6_RXO3+
G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
R1_RXOCR0_RXOC+
G3_RXE0G2_RXE0+
G1_RXE1G0_RXE1+
B7_RXE2B6_RXE2+
B5_RXECB4_RXEC+
B3_RXE3B2_RXE3+
B5_RXECB4_RXEC+
B
B
3D_SOCKET
2
1
2
3
+5V_Normal
NC/100
R168
SG_SYNC
D347
NC
1
CN35
CON03
A
A
Title
Size
B
Date:
5
4
3
2
MSD3393
Document Number
Rev
1.0
LVDS Interface
Saturday, June 08, 2013
Sheet
1
3
of
9
5
4
3
2
1
VIDEO OUT
C102
+5V_Normal
AV IN
R78
0.1uF/0402/16V
470R/0402/5% R208
20K/0402/5%
P1
2
4
6
R76
1
10K/0402/5%
R77
3
10K/0402/5%
R79
AV1
C86
12K/0402/5%
220pF/0402/16V/NC 220pF/0402/16V/NC
C87
5
R209
AV1-Rin
AVOUT-V R155
75R/0402/5%
D
3
3906/SOT23
Q17
Q18
3904/SOT23
R206
75R/0402/5%
AV1-Lin
1
C97
CVBS1_OUT
10uF/0603/16V
2
D
R207
12K/0402/5%
R154
75R/0402/5%
R80
12K/0402/5%
TP1
RCA-3P
75R/0402/5%
FOR ATV/AV DEBUG
C
C
SPDIF OUT
CN42
YPBPR
1
P2
PHONEJACK STEREO 180D
RCA1_180D
2SPDIF_O
3
R81
R82
330R/0402/5%
SPDIF_OUT
C88
100R/0402/5%
33pF/0402/16V
1
2
YPbPr_PR
3
YPbPr_PB
4
YPbPr_Y
Closed to IC
B
B
Close to Mstar IC
R83
R84
R85
75R/0402/5%
75R/0402/5%
75R/0402/5%
A
A
Title
Size
B
Date:
5
4
3
2
MSD3393
Document Number
Rev
1.0
Video Interface
Saturday, June 08, 2013
Sheet
1
4
of
9
5
4
3
VGA
2
1
P4
D
16
VGA AUDIO IN
D
11
1
6
2
7
3
8
4
9
5
10
12
13
14
17
15
VGA-Rin
VGA-Gin
VGA-Bin
PHONEJACK STEREO 90D
1
2
10K/0402/5% VGA-Lin_AU
VGA-Lin_AU
R87
10K/0402/5% VGA-Rin_AU
VGA-Rin_AU
3
VGA/15 PIN
R88
12K/0402/5%
4
DDC_SCL_D
DDC_SDA_D
C
R86
100R/0402/5%
100R/0402/5%
P5
UART_RX
UART_TX
R90
R91
R89
12K/0402/5%
C89
220p/0402/16V
C90
220p/0402/16V
C
VGA_VSYNC
VGA_HSYNC
R93
10K/0402/5%
R92
10K/0402/5%
B
B
VGA-Bin
VGA-Gin
VGA-Rin
VGA-Bin
VGA-Gin
VGA-Rin
R94
R95
R96
75R/0402/5%
75R/0402/5%
75R/0402/5%
Close to Mstar IC
A
A
Title
Size
MSD3393
Document Number
Date:
5
4
3
Rev
1.0
VGA Interface
A
Saturday, June 08, 2013
2
Sheet
5
of
1
9
5
4
3
USB INTERFACE
D
2
1
USB POWER
D
P6
USB_A
5
6
5
6
1
2
3
4
1
2
3
4
USB1_D1-_in
USB1_D1+_in
+5V_USB0
R97
R98
5.1/0402/5%
5.1/0402/5%
USB1_DUSB1_D+
USB1_DUSB1_D+
5V_USB
D2
+5V_Normal
5V_USB
+5V_USB0
C92
C91
2.2uF/0603/16V
0.1uF/0402/16V
C
USB_A
5
5
6
6
1
2
3
4
P7
1
2
3
4
USB2_D1-_in
USB2_D1+_in
+5V_USB0
Note:电容靠近USB(CN600)端子,提供usb读写稳定性
R99
R100
5.1R
5.1R
USB2_DUSB2_D+
+5V_USB0
USB2_DUSB2_D+
C
5V_USB
C94
C93
2.2uF/0603/16V
0.1uF/0402/16V
Note:5.1R电阻靠近端子,减小ESD.
Note:电容靠近USB(CN601)端子,提供usb读写稳定性
USB ESD分布电容要求<2pF
B
B
A
A
Title
Size
MSD3393
Document Number
Date:
5
4
3
Rev
1.0
USB Interface
A
Saturday, June 08, 2013
2
Sheet
6
of
1
9
5
4
3
2
1
P8
+5V
CEC/DDC GND
DDC SCL
DDC SDA
CEC
HPD
靠近端子放置
18
17
15
16
13
19
HDMI3/5V
HDMI3-DDC-SCL
HDMI3-DDC-SDA
CEC
HDMI3-HPD
R101
HDMI3-RX2P
5.1R/0402/5%
HDMI3_RX2N
HDMI3_RX1P
R103
R107
HDMI3-RX2N
5.1R/0402/5%
HDMI3-RX1P
5.1R/0402/5%
HDMI3_RX1N
HDMI3_RX0P
R108
R109
HDMI3-RX1N
5.1R/0402/5%
5.1R/0402/5%
HDMI3-RX0P
HDMI3_RX0N
HDMI3_CLKP
R111
R113
HDMI3-RX0N
5.1R/0402/5%
5.1R/0402/5%
HDMI3-CLKP
HDMI3_CLKN
R115
5.1R/0402/5%
HDMI3-CLKN
R102
HDMI0-RX2P
R106
R104
HDMI0-RX2N
HDMI0-RX1P
HDMI0-RX1N
HDMI0-RX0P
HDMI0-RX0N
HDMI0-CLKP
R105
10K/0402/5%
1K/0402/5%
HDMI3-HPD
HDMI3-DDC-SCL
HDMI3-DDC-SDA
10K/0402/5%
R110
R112
33R/0402/5%
HDMI0-SCL
33R/0402/5%
HDMI0-SDA
2
2
5
8
11
Dat2 shield
Dat1 shield
Dat0 shield
clk shield
HDMI3/5V
HDMI3/5V
HDMI3_RX2P
10K/0402/5%
3
20
21
22
23
GND
GND
GND
GND
Q10
1R114
HDMI0-HPDIN
4.7K/0402/5%
HDMI0-HPDIN
3904/SOT-23
HDMI0-CLKN
D
D
7
9
4
6
1
3
10
12
14
DAT0+
DAT0DAT1+
DAT1DAT2+
DAT2clk+
clkARC1
HDMI3_RX0P
HDMI3_RX0N
HDMI3_RX1P
HDMI3_RX1N
HDMI3_RX2P
HDMI3_RX2N
HDMI3_CLKP
HDMI3_CLKN
HDMI_ARC
HDMI3
HDMI
P9
DAT0+
DAT0DAT1+
DAT1DAT2+
DAT2clk+
clkARC1
C
18
17
15
16
13
19
HDMI1/5V
HDMI1-DDC-SCL
HDMI1-DDC-SDA
CEC
HDMI1-HPD
2
5
8
11
7
9
4
6
1
3
10
12
14
HDMI1_RX2P
R116
HDMI1-RX2P
5.1R/0402/5%
HDMI1_RX2N
HDMI1_RX1P
R117
R119
HDMI1-RX2N
5.1R/0402/5%
HDMI1-RX1P
5.1R/0402/5%
HDMI1_RX1N
HDMI1_RX0P
R121
R123
HDMI1-RX1N
5.1R/0402/5%
5.1R/0402/5%
HDMI1-RX0P
HDMI1_RX0N
HDMI1_CLKP
R125
R126
HDMI1-RX0N
5.1R/0402/5%
5.1R/0402/5%
HDMI1-CLKP
HDMI1_CLKN
R130
5.1R/0402/5%
HDMI1-CLKN
HDMI1/5V
HDMI1-RX2P
R118
R120
HDMI1-RX2N
HDMI1-RX1P
R124
R122
1K/0402/5%
HDMI1-RX1N
HDMI1-RX0P
10K/0402/5%
10K/0402/5%
HDMI1-RX0N
HDMI1-CLKP
HDMI1-DDC-SCL
HDMI1-DDC-SDA
HDMI1-HPD
3
+5V
CEC/DDC GND
DDC SCL
DDC SDA
CEC
HPD
HDMI1/5V
R127
R129
33R/0402/5%
HDMI1-SCL
33R/0402/5%
HDMI1-SDA
2
GND
GND
GND
GND
Dat2 shield
Dat1 shield
Dat0 shield
clk shield
靠近端子放置
20
21
22
23
HDMI1-CLKN
10K/0402/5%
Q11
1R128
4.7K/0402/5%/NC
HDMI1-HPDIN
HDMI1-HPDIN
3904/SOT-23
HDMI1_RX0P
HDMI1_RX0N
HDMI1_RX1P
HDMI1_RX1N
HDMI1_RX2P
HDMI1_RX2N
HDMI1_CLKP
HDMI1_CLKN
C
HDMI1
HDMI
P10
20
21
22
23
GND
GND
GND
GND
18
17
15
16
13
19
+5V
CEC/DDC GND
DDC SCL
DDC SDA
CEC
HPD
HDMI2/5V
HDMI2-DDC-SCL
HDMI2-DDC-SDA
CEC
HDMI2-HPD
2
5
8
11
Dat2 shield
Dat1 shield
Dat0 shield
clk shield
MHL_CD_SENSE
MHL,上拉电压必须为此,SCL上拉电阻47K
AVDD5V_CD
7
9
4
6
1
3
10
12
14
DAT0+
DAT0DAT1+
DAT1DAT2+
DAT2clk+
clkARC1
靠近端子放置
HDMI2_RX0P
HDMI2_RX0N
HDMI2_RX1P
HDMI2_RX1N
HDMI2_RX2P
HDMI2_RX2N
HDMI2_CLKP
HDMI2_CLKN
HDMI2_RX2P
R131
0R/0402/5%
HDMI2-RX2P
HDMI2_RX2N
HDMI2_RX1P
R132
R133
HDMI2-RX2N
0R/0402/5%
0R/0402/5%
HDMI2-RX1P
HDMI2_RX1N
HDMI2_RX0P
R134
R137
0R/0402/5%
HDMI2-RX1N
HDMI2-RX0P
0R/0402/5%
HDMI2_RX0N
HDMI2_CLKP
R139
R141
0R/0402/5%
HDMI2-RX0N
HDMI2-CLKP
0R/0402/5%
HDMI2_CLKN
R143
HDMI2-CLKN
0R/0402/5%
HDMI2-RX2P
HDMI2-RX2N
HDMI2-RX1P
R135 R136
47K/0402/5%
HDMI2-RX1N
HDMI2-RX0P
10K/0402/5%
HDMI2-HPD
HDMI2-DDC-SCL
HDMI2-DDC-SDA
HDMI2-RX0N
HDMI2-CLKP
R140
R142
不需要MHL功能，R709/R710的上拉可为HDMI2/5V,电阻值为10K
HDMI2-HPDIN
33R/0402/5%
HDMI2-HPDIN
IC内置hotplug电路
B
HDMI
CEC & ARC
MHL
HDMI-ARC
C95
2.2uF/0603/16V
HDMI-ARC
HDMI2/5V
CEC
R144
200R/0402/5%
HDMI-CEC
+5V_Standby
R148
AVDD5V_CD
+5V_Normal
4.7K/0402/5%
ARC_DET
0R/0402/5%
HDMI2/5V
R150
10K/0402/5%
R146
MHL_CD_SENSE
AVDD5V_MHL
100R/0402/5%
MHL_CABLE-DET
D3
2
R149
C96
300K/0402/5%
47nF/0402/16V
3
根据ARC所放的HDMI定
HDMI2/5V
HDMI-CEC
R145
HDMI3/5V
1
BAT54C/SOT23/NC
R152
R151
10K/0402/5% 4
10R/0402/5%
MHL_VBUS-EN
更新为此
R147 10K/0402/5%/NC
QA1
5
3
VIN
/OC
/EN
GND
HDMI_ARC
VOUT
1
2
B
R138
33R/0402/5%
HDMI2-SCL
33R/0402/5%
HDMI2-SDA
HDMI2-CLKN
AP2181DWG-7
电阻必须300K
平台不需要MHL功能，此部分电路不需要
HDMI2 With MHL
A
A
Title
MSD3393
Size
Document Number
D
Date:
5
4
3
2
Rev
1.0
HDMI Interface
Saturday, June 08, 2013
1
Sheet
7
of
9
5
4
3
2
1
Silicon TUNER
+3.3V_TU
+3.3V_TU
+3.3V_TU
D
C99
L29
L25 270nH/0603/ 5%
270nH/0603/ 5%
25
26
C183
180pF/0402/16V
27
28
C
29
+3.3V_TU
15
XOUT
LDO_ADJ
RF_IN
ALIF_N
RF_SHIELD
DLIF_P
Si2158
ADDR
+3.3V
U10
RSTB
DLIF_N
AGC1
+1.8V
GND_EPAD
2
3
3
16
17
XTAL_I/RCLK
19
20
18
XTAL_O
GND
+3.3V
ALIF_P
1
AGND
+1.8V
14
+1.8V_TU
13
R203
100R/0402/5%
IF-IN+
12
R204
100R/0402/5%
IF-IN-
11
10
+3.3V_TU
9
8
+1.8V_TU
C
GND
180nH/0603/ 5%
C182
2.2uF/0402/16V
RF_IP
+3.3V
L23
Q16
3906/SOT-23+1.8V_TU
7
L22
270nH/0402/ 5%
SDA
R158
0R/0402/5%
5
R157
0R/0402/5%
RF_REF
SCL
16
17
1.2nF/0402/16V
22
C174
L28
L26
270nH/0603/ 5% 270nH/0603/ 5%
L24
C175
180pF/0402/16V 23
100pF/0402/16V
0R/0402/5%
C176
180pF/0402/16V 24
AGC2
47pF/0402/16V
C172
C173
GPIO2
AGND
0.1uF/0402/16V
3
2
+3.3V
AGND
C101
120pF/0402/50V
Y2
24.000MHz
68pF/0402/16V
1nF/0402/16V
21
PE42750DS/NC
U9
12pF/0402/16V/NC
close 20pin C180
C179
68pF/0402/16V
C169
12pF/0402/16V/NC
1
C181
6
C178
C177
GPIO1
VDD 12
C1 11
10
C2
AGND
R205
3.3R/0402/1%
24 MHz /ESR< 120 , CL=8pF
2158 FOR LOW SINGER WATER WAVE
2157 CAN CANCLE
2
1
0.1uF/0402/16V/NC
AGND
GND 9
RF2 8
GND 7
C1
C100
120pF/0402/50V/NC
4
GND
5 RFC
6 GND
CON43RCA1_6
3
4
5
6
7
AGND
1
GND
2 RF1
3 GND
4
47nF/0402/16V/NC
AGND
D
L27
600R/0402/500mA
R153
100R/0402/5%/NC
C98
+1.8V_TU
0R/0402/5%
C170
R201
+3.3V_TU
R202
C166
C167 C168
1nF/0402/16V
1nF/0402/16V
1nF/0402/16V
0R/0402/5%
C171
1nF/0402/16V
SDA-T
C1
SCL-T
IF_AGC
1nF/0402/16V
DIF IN&OUT
AGC RC Filter &I2C
B
TUNER POWER
B
+3.3V_Normal
10K/0402/5% R160
C132 L12 0R/0603/5%
20pF/0402/16V/NC
510R/0402/5%/NC
C126
L11 0R/0603/5%
OUT
OUT
4
IN
1
3
+3.3V_TU
+5V_Normal
C125
20pF/0402/16V/NC
Close MSD IC
VIFP
IFP
0.1uF/0402/16V
C130
C131
10uF/0805/16V
IF-IN+
100R/0402/5%
TUNER_SCL
C124
R164
10uF/0805/16V
C123
33pF/0402/16V/NC
100R/0402/5%
TUNER_SDA
R163
C129
L10 0R/0603/5%
C122
56pF/0402/16V
R162
SCL-T
C127
10uF/0805/16V
IF_AGC
100pF/0402/16V
R165
C133
IFAGC-T
100R/0402/5%
IFAGC-T
0.1uF/0402/16V
0.1uF/0402/16V
0R/0603/5%
VIFM
IFN
0.1uF/0402/16V
C128
L9
BPF_IN
C121
0.1uF/0402/16V
IF-IN-
SDA-T
2
10K/0402/5% R161
C120
100pF/0402/16V
ADJ
U11
ASM1117-3.3_1A
Close Tuner
A
A
Title
MSD3393
Size
C
Date:
5
4
3
2
Document Number
Rev
1.0
Tuner
Thursday, June 20, 2013
Sheet
1
8
of
9
5
4
3
2
1
L13
TPA3110
AU. AMP
VCC-AMP
D
+12V_NORMAL
0.1uF/0402/16V
C163
150R/0402/5%
L1
C138
MUTE_AMP
R172 1K/0402/5%
1
2
47K/0402/5%
3
L1
R175
4
150R/0402/5%
6
C156
R185
2.2nF/0402/50V/NC 47K/0402/5%
C
R186
R190
R184
R1
0.1uF/0402/16V
8
C154
R187
4.7K/0402/5%
9
22K/0402/5%
10R/0402/5%
150R/0402/5%
22K/0402/5% R183
C136
R189
22K/0402/5%/NC
22K/0402/5%/NCR179
7
1uF/0603/16V
C155
C157 R191
3K/0402/5% 1uF/0603/16V
1uF/0603/16V
10
11
12
C159
220nF/0402/16V 13
VCC-AMP
R1
+12V_NORMAL
PVCCL
SD
PVCCL
FAULT
PVCCL
LINP
BSPL
LINN
OUTPL
GAIN0
PGND
GAIN1
OUTNL
AVCC
BSNL
AGND
BSNR
GVDD
OUTNR
PLMIT
PGND
RINN
OUTPR
RINP
BSPR
NC
PBTL
29
14
R192
150R/0402/5%
C137
220nF/0805/50V
L15 0R/1206/5%
PVCCR
PVCCR
28
C143
220nF/0603/50V
27
1
26
L16
22uH/2.7A/NC
2
L17 0R/1206/5%
25
+5V_Normal
CON2
R198
100K
1
2
C145
2X2.0MM
220nF/0805/50V
PH-Lout
CA24
24
MUTE_EAR
C146
220nF/0603/50V
23
22
1
C153
21
L19 0R/1206/5%
220nF/0603/50V
20
19
1
18
C158
17
L20
22uH/2.7A/NC
2
L21 0R/1206/5%
220nF/0603/50V
C161
AV_AUOUTL1
AV_AUOUTL1
C311
3
2.2uF
R211
100
4
C152
220nF/0805/50V
CON3
2
1
C59
2.2uF
OUT1
VCC
MUTE
OUT2
IN1
GND
BH3544
BIAS
IN2
8
7
CA25
100uF/16V
PH-Rout
6
5
C312
R210
+
2.2uF
AV_AUOUTR1
AV_AUOUTR1
100
+
CA18
47uF/16V
CA19
47uF/16V
C
2X2.5MM
C160
220nF/0805/50V
16
15
2
L18
22uH/2.7A/NC
2
D198
1N4148
U13
1
100uF/16V
+
C144 220nF/0402/10V 5
LINEOUT_APMR
1
100K/0402/5%
100K/0402/5% U12
R171
2.2nF/0402/50V/NC
C135
R167
R169
1uF/0603/16V
0.1uF/0402/16V
GVDD
C164
R166
LINEOUT_APML
L14
22uH/2.7A/NC
2
+
D
0R/1206/5%
+12V_NORMAL
+ CA1
0.1uF/0402/16V
100uF/35V/ECS-5M
VCC-AMP
IC-TPA3121D2_0
P3
PHONEJACK STEREO 180D
+5V_Normal
1
R285
NC\0
R284
0\NC
D6
D4
R246
100K
MUTE_EAR
3
PWD_MT
Q22
MMBT3906
R286 10K
1N4148
+5V_Standby
+ CA55
100uF/16V
B
1
Q24
3904
2
0
PH-Rout
MUTE_AMP
R283
470
1N4148
R247
PH-Lout
3
4
R248
470
B
2
R293
47K
4.7K/NC
R310
MUTE_AMP
D7
BAV70
3
2 AMP-MUTE
R299
1
Q25
3904
2
H: MUTE, L: UN-MUTE
R287 10K
47K
A
A
Title
MSD3393
Size
Custom
Date:
5
4
3
2
Document Number
Rev
1.0
Amplifier
Thursday, June 20, 2013
1
Sheet
9
of
9
RP29
100/0.25W
RPA29
FP2
100/0.25W
CP12
471/1KV
FUSE T2A 250VAC
CP3
392/630V
CY104
471/400VAC
DP8
5397
+24V
DP11
TP7
+ CP15
1000U 35V
SB10200
+ CP19
1000U 35V
CP14
104
RP42
1.5K/2W
3
QP1
DP7
LL4148
QP6
8050
CP13
7
Aging socket
4
1
RP41
1
RP16
470K/1/6W
5
ZD206
3.3V
6
CP4 471
CP5
104
ZD204
30V
RP11
220K/1/4W
7
8
RP17
100K
ICP1
TEA1733
5
4
6
3
7
2
8
1
4
RP24
1K/1/6W
RP40
4.7K/1/6W
RP23
10K/1/6W
8(NC)
2
ZD202
5V1/1W
CP9
102
CP10
224
2
9
10(NC)
12
RP26
0.15/2W
DP5
IN4007
CP7
DP6
IN4007
CP17
1000UF25V
CP18
1000uF/25V
Aging socket
CNV12
NC / SIP2_2.0mm
DP13
LL4148
RP36
39K/1/6W
DP14
LL4148
CY105
101/400VAC
RP31
220/1/6W
RP7
1M/1/4W
A2
ICP2
PC817C
RP8
1M/1/4W
RP4
1M/1/4W
RP1
1M/1/4W
1M/1/4W
RP3
4
1
3
2
RP32
1K/1/6W
CP23
224
RP33
10K/1/6W
100K/1/4W
RP20
QP5
8050
ICP3
TNR101
INPUT: 90-264V AC
FP1
HSP1
1
2
3
4
RP34
10K/1/6W
RP37
10K/1/6W
RP35
NC
OUTPUT: +25V/1.7A
+12V/2A
1
2
3
FUSE T3.15A 250VAC
L
CP22
104
TL431
SPECIFICATION
RP38
1K/1/6W
1
2
CX102
474/275VAC
L
RP43
4.7K/1/6W
6
TRANSFORMER S
RP6
1M/1/4W
RP2
1M/1/4W
N
ZD302
33V
CP16
104
CY103
NC
RP5
1M/1/4W
4
LF101
10MH
CY 106
101/400VAC
CP8
104
+
3
1
A1
154
RP19
10M/1/8W
CP20
1000uF/25V
+
5
RP27
4R7/1/4W
+ CP11
4.7U 50V
CY 102
471/400VAC
474/275VAC
3
CX101
2
102
CP6
+
SB10100
11
ZD201
27V
0U7H
DP10
ZD303
15V
DP9
1N4007
RP18
10K
+12V
LP2
1
ZD205
18V
RP25
22K/1/6W
3
1
RP30
RPA30
47/0.25W 47/0.25W
3
RP22
10R/1/6W
2
RP12
10M/1W
RP13
10M/1W
RP21
33R/1/8W
1
TH101
RP15
10M/1W
CNV24
NC / SIP2_2.5mm
1K/1/6W
102/1KV
RP14
10M/1W
CY 101
471/400VAC
+24V_Normal
ZD301
30V
3
DP4
RL256
DPA8
5397
CP2
68U 450V
2
DP3
RL256
+
CP1
68U 450V
1
2
+
1
2
DP2
RL256
2
DP1
RL256
RP28
100K 2W
CN101
Title
3.5Frame
Size
C
Date:
Document Number
<Doc>
Sunday , September 29, 2013
Rev
<Rev Code>
Sheet
1
of
1
CP36
471/1KV
LP3
100uH
QP4
RP39
100/0.25W
BL-ON/OFF
10K
DP12
4148
ISENSE
+ CP33
CP34
104/100V
RP46
RP47
2R2/0805 10K/0805
82UF/100V
+ CP37
82UF/100V
UP4
1
RP58
VIN
UVLO
VSEN
OVP 3.02
RP57
200K/1206
28
180K
CP25
10nF
RP64
51K
RP51
BL-ADJUST
RP50
100K
2
EN
3
PWM1
FAULT
27
FSW
26
ZDP13 RP48 RP53 RP76 RP79
6.2V
0R47/1206*4
DRV
LEDB1
LEDB2
LEDB3
LEDB4
LEDB5
LEDB6
CN400
CN10_2.0
1
2
3
4
5
6
7
8
9
10
LED1
LED2
LED3
LED4
LED5
LED6
RP59
200K
4
PWM2
5
PWM3
TPS61196
CP32
10nF
RP54
*
RP55
*
41
40
39
38
37
36
35
34
33
32
31
30
29
RP60
200K
RP52
2
1
CP26
2.2uF
LED+
CP35
471/1KV
11
12
+12V
LED+
ZDP12
15V
RP45
2R2
RP44
100/0.25W
DP15
3
+24V_Normal
+24V
VDD
25
GDRV
24
6
PWM4
ISNS
23
7
PWM5
PGND
22
DRV
CP31
470pF
RP61 470 ISENSE
CP28
1uF
ZDP15
7.5V/1206
10K
ZDP16
7.5V/1206
RP62 390K
RP10 390K
RP9 *
8
PWM6
REF
21
9
FBP
COMP
20
10
ISET
OVP
19
RP80
VSEN
CP27
220pF
CP29
2.2uF
100K
RP71 *
11
IFBV
AGND
18
RP63 62K
12
IFB1
IFB6
17
13
IFB2
IFB5
16
RP56
150K CP24
47nF
LEDB6
RP72
LED6
1R
CP30
0.1uF
IFB3
IFB4
15
LED5
1R
RP74
LEDB1
LEDB4
LED4
48
49
46
47
1R
42
43
44
45
14
LEDB5
RP73
RP88
RP85
LEDB3
RP75
LED3
RP86
1R
LEDB2
LED2
*
*
LED1
*
RP65
*
ZDP11
27V
RP66
*
ZDP10
27V
RP67
*
ZDP3
27V
RP68
*
ZDP2
27V
RP69
*
ZDP4
27V
ZDP5
27V
RP70
*
RP87
*
RP77
1R
RP78
1R
Title
3.5Frame
Size
B
Date:
Document Number
<Doc>
Friday , September 27, 2013
Rev
<Rev Code>
Sheet
1
of
1