Download Sony TA-N1

TA-N1
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
SPECIFICATIONS
STEREO POWER AMPLIFIER
MICROFILM
1
SAFETY CHECK-OUT
TABLE OF CONTENTS
After correcting the original service problem, perform the following safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
1. SERVICE NOTE ................................................................ 3
LEAKAGE
The AC leakage from any exposed metal part to earth Ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale.
The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are suitable. (See Fig. A)
1.5kΩ
3. ELECTRICAL ADJUSTMENT ..................................... 7
4. DIAGRAMS
4-1. Circuit Boards Location ........................................................ 7
4-2. Schematic Diagram – Main L Section – ............................... 8
4-3. Printed Wiring Board – Main L Section – ............................ 9
4-4. Schematic Diagram – Main R Section – ............................. 10
4-5. Printed Wiring Board – Main R Section – .......................... 11
4-6. Schematic Diagram – Input Section – ................................ 12
4-7. Printed Wiring Board – Input Section – .............................. 13
4-8. Schematic Diagram – Power Section – ............................... 14
4-9. Printed Wiring Board – Power Section – ............................ 15
5. EXPLODED VIEWS
5-1. Top and Back Panel Section ................................................ 16
5-2. Front Panel Section ............................................................. 16
5-3. Heat Sink Section ................................................................ 17
5-4. Bottom Plate and Frame Section ......................................... 18
6. ELECTRICAL PARTS LIST ................................... 19
To Exposed Metal
Parts on Set
0.15µF
2. GENERAL ........................................................................... 5
AC
voltmeter
(0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
MODEL IDENTIFICATION
— BACK PANEL —
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS
QUE PAR DES PIÈCES SONY DONT LES NUMÉROS
SONT DONNÉS DANS CE MANUEL OU DANS LES
SUPPLÉMENTS PUBLIÉS PAR SONY.
2
Parts No.
PARTS No.
4-217-757-1π
4-217-757-2π
MODEL
US , CND
AEP, UK, E, AUS
• Abbreviation
CND : Canadian model
AUS : Australian model
SECTION 1
SERVICE NOTE
• SERVICE POSITION
When performing servicing, use a table about 15 cm as shown in
the figure.
EPT506
FPT558
CN554 (Red) 2P
CN654 (Red) 4P
CN702 (Black) 4P
CN701 (White) 4P
CN201 (Red) 4P
CN751 (Red) 4P
CN852 (Red) 4P
CN604 (White) 4P
• REPLACING THE POWER TRANSISTOR
When replacing the power transistors (Q304 to Q313: L-ch, Q404
to Q413: R-ch), replace all ten together.
• SECURING THE GRILL (A)
When securing the grill (A) to the top panel, use the Sony bond
SC608LV (7-432-912-48). ( )
Top panel (Buttom side)
L ch : Q304 to Q313
R ch : Q404 to Q413
Grille (A)
3
• NOTE ON ARRANGING WIRES
As how the wires in this unit are drawn affect the sound quality,
note down the positions of wires before beginning servicing.
After repairs, arrange the wires as follows.
A : After binding wires, push down.
B : Bind avoiding touching the heatsink.
C : Bind avoiding touching the wires below (binder A).
D : Arrange so that the wires from CN802 pass below the wires
from CN2.
Lead pin
CN2
AC/PS board
Heatsink
CN802
D
B
C
Lead pin
Lead pin
Lead pin
PS B
board
INPUT board
A
4
SECTION 2
GENERAL
This section is extracted from
instruction manual.
5
6
TA-N1
SECTION 3
ELECTRICAL ADJUSTMENT
SECTION 4
DIAGRAMS
BIAS CURRENT ADJUSTMENT
4-1. CIRCUIT BOARDS LOCATION
• As the voltage changes according to the time the power is supplied, adjust correctly according to the following procedure.
MAIN L board
Connection:
Digital voltmeter
MAIN-L, R boards
INPUT board
TP301 to 305 (L-CH), TP401 to 405 (R-CH)
TP306 (L-CH), TP406 (R-CH)
Procedure:
1. Measure the voltage at the five measuring points just after supplying the power, and adjust RV301 (L-CH) and RV401 (R-CH)
so that the measuring point with the lowest voltage becomes
approx 15 mV.
Measuring Point
Adjusting Point
L-CH Between the 5 measuring points
(+) TP301, TP302, TP303,
TP304, TP305 and TP306 (–)
RV301
R-CH Between the 5 measuring points
(+) TP401, TP402, TP403,
TP404, TP405 and TP406 (–)
RV401
2. Leave for one hour with the power supplied. (Aging)
3. Measure the voltage at the respective measuring points and adjust RV301 (L-CH) and RV401 (R-CH) so that the voltages become within the ranges shown in the following table. Adjust to
the voltage with the highest priority shown in the table as much
as possible.
Priority Order
AC SW board
19.8 mV to 22.0 mV
2nd
19.8 mV to 24.2 mV
3rd
18.7 mV to 24.2 mV
4th
18.7 mV to 25.2 mV
5th
15.0 mV to 25.2 mV
PS B board
AC/PS board
Adjusting Value
1st (Highest priority)
MAIN R board
LED board
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
4. Leave for another 30 minutes if the adjustment control has been
rotated.
5. Measure the voltage again and check that it is within the adjusting value. If outside, repeat from step 3 again.
6. Be sure to perform aging for more than 30 minutes if the adjustment control has been rotated. Finally check the voltage before
ending the adjustment.
For schematic diagrams.
For printed wiring boards.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
Note:
• X : parts extracted from the component side.
®
•
: Through hole.
• b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Note:
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part
number specified.
Note:
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
S : B+ Line.
T : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground in
playback mode.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Signal path.
F : AUDIO
•
•
•
•
7
7
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
TA-N1
4-2. SCHEMATIC DIAGRAM – MAIN L SECTION –
(Page 12)
(Page 14)
(Page 14)
8
(Page 12)
8
(Page 14)
TA-N1
4-3. PRINTED WIRING BOARD – MAIN L SECTION –
• Refer to page 7 for Circuit Boards Location.
INPUT
BOARD
PS B
BOARD
(Page 13)
(Page 13)
Location
Ref. No
Location
D301
D302
D303
D304
D305
D306
D307
D308
C-9
B-4
B-4
B-5
B-5
B-2
B-3
A-2
IC301
A-12
Q301
Q302
Q303
Q304
C-8
B-4
B-5
D-13
Q305
Q306
Q307
Q308
Q309
Q310
Q311
Q312
Q313
Q314
Q315
Q316
Q317
Q318
Q319
D-11
D-10
D-9
D-8
D-6
D-5
D-4
D-3
D-1
B-3
A-3
A-12
A-12
A-11
A-11
9
AC / PS
BOARD
(Page 15)
• Semiconductor Location
Ref. No
AC / PS
BOARD
9
INPUT
BOARD
(Page 15)
(Page 13)
TA-N1
4-4. SCHEMATIC DIAGRAM – MAIN R SECTION –
(Page 14)
C413
330
80V
C412
330
80V
(Page 14)
(Page 12)
10
10
(Page 12)
(Page 14)
TA-N1
4-5. PRINTED WIRING BOARD – MAIN R SECTION –
• Refer to page 7 for Circuit Boards Location.
PS B
BOARD
(Page 13)
(Page 15)
(Page 15)
AC / PS
BOARD
AC / PS
BOARD
• Semiconductor Location
Ref. No
Location
Ref. No
Location
D401
D402
D403
D404
D405
D406
D407
D408
C-9
C-5
C-5
C-4
C-4
C-2
C-2
D-2
IC401
D-12
Q401
Q402
Q403
Q404
C-8
C-5
C-4
A-13
Q405
Q406
Q407
Q408
Q409
Q410
Q411
Q412
Q413
Q414
Q415
Q416
Q417
Q418
Q419
A-11
A-11
A-9
A-8
A-6
A-5
A-4
A-3
A-2
C-3
D-3
D-12
D-12
D-11
D-11
11
11
(Page 15)
AC / PS
BOARD
(Page 15)
AC / PS
BOARD
TA-N1
4-6. SCHEMATIC DIAGRAM – INPUT SECTION –
(Page 8)
(Page 14)
(Page 14)
(Page 8)
(Page 14)
(Page 10)
(Page 10)
(Page 14)
12
12
TA-N1
4-7. PRINTED WIRING BOARD – INPUT SECTION –
• Refer to page 7 for Circuit Boards Location.
AC / PS
BOARD
MAIN-L
BOARD
AC / PS BOARD
(Page 15)
(Page 9)
(Page 15)
MAIN-R
BOARD
MAIN-L
BOARD
(Page 11)
(Page 9)
AC / PS
BOARD
(Page 15)
• Semiconductor
Location
Ref. No
Location
D101
D102
D103
D203
A-7
A-6
A-3
A-3
Q101
Q102
Q103
Q111
Q112
Q113
Q203
A-6
A-6
A-4
A-6
A-6
A-3
A-4
AC / PS
BOARD
(Page 15)
(Page 9)
MAIN-L
BOARD
13
13
TA-N1
4-8. SCHEMATIC DIAGRAM – POWER SECTION –
(Page 12)
(Page 8)
(Page 8)
(Page 12)
(Page 8)
(Page 10)
(Page 12)
(Page 10)
(Page 10)
(Page 12)
14
14
TA-N1
4-9. PRINTED WIRING BOARD – POWER SECTION –
• Refer to page 7 for Circuit Boards Location.
INPUT
BOARD
(Page 13)
PS B
BOARD
(Page 13)
MAIN-R
BOARD
PS B
BOARD
MAIN-R
BOARD
(Page 11)
(Page 13)
INPUT
BOARD
(Page 13)
MAIN-L
BOARD
(Page
9)
(Page 11)
MAIN-R
BOARD
(Page 11)
(Page 11)
MAIN-R
BOARD
EXCEPT
US, CND
• Semiconductor Location
Ref. No
Location
Ref. No
Location
D1
D2
D3
D501
D551
D601
D602
D651
D652
D701
D702
D751
D752
D801
D802
D803
D804
E-8
E-8
E-8
B-2
E-2
C-4
C-3
C-4
C-3
C-6
C-6
C-6
C-6
F-3
E-3
F-3
F-3
D805
D806
D901
D902
E-3
F-6
B-8
B-8
Q1
Q701
Q702
Q751
Q752
Q801
Q901
Q902
Q903
Q904
Q905
E-8
C-6
B-6
D-6
E-6
E-6
A-8
A-7
A-8
A-6
B-8
(Page 9)
MAIN-L
BOARD
15
15
FH 1
FH 3
FH 2
FH 4
SECTION 5
EXPLODED VIEWS
NOTE:
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE)
Â
Cabinets color
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
• The mechanical parts with no reference number in
the exploded views are not supplied.
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
• Abbreviation
CND : Canadian model
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
5-1. TOP AND BACK PANEL SECTION
16
not supplied
Supplied with TB451
18
8
11
16
4
HEATSINK (L) BLOCK
HEATSINK (R) BLOCK
13
14 (US,CND)
14
17
#6
13
16
11
5-2. FRONT PANEL SECTION
67
TB451
16
11
11
17
16
9
70
not supplied
TB351
11
16
#5
14
66
#9
11
not supplied
#5
3
10
#5
#5
#5
#3
7
12 6
#5
not supplied
#5
3
13
#1
#3
#5
#5
CNJ1
#6
#5
66
#5
15
(US,CND)
#9
69
#5
Supplied with TB351
2
2
#3
4
#5
70
68
#5
65
#5
not supplied
#4
#5
#5
1
#4
#6
69
64
#5
71
#5
#5
#3
#6
69
71
#5
#5
#2
#5
#5
62
10
#5
#5
#5
56
#5
#2
#6
#5
63
69
#5
#2
61
62
59
55
51
5
53
#2
57
54
72
60
58
not supplied
52
#5
Ref. No.
Part No.
Description
1
2
3
4
5
4-217-753-01
4-935-228-11
3-703-685-41
4-219-096-01
1-673-331-11
PANEL, TOP
GRILLE (A)
SCREW (+BV 3X8)
BOLT (M5X16), 6 SQUARE HOLE
INPUT BOARD
Remark
6
7
8
8
9
4-987-527-01
4-217-756-11
4-217-757-11
4-217-757-22
4-218-397-11
KNOB (VOL)
PANEL (C), BACK
PANEL (A), BACK (US,CND)
PANEL (A), BACK (EXCEPT US,CND)
BRACKET (SPEAKER T)(EXCEPT US,CND)
9
10
11
4-218-397-21 BRACKET (SPEAKER T)(US,CND)
4-217-770-01 REINFORCEMENT (R)
4-217-765-01 ESCUTCHEON
Ref. No.
12
13
14
15
16
17
* 18
CNJ1
TB351
TB351
TB451
TB451
Part No.
Description
Remark
4-219-878-01 ESCUTCHEON (KNOB)
4-974-510-01 SCREW (+BV 3X8 CU)
4-911-049-21
3-701-505-00
4-219-097-01
3-696-090-11
3-703-044-11
SCREW (3X8)
SET SCREW, DOUBLE POINT 3X3
BOLT (M4X12), 6 SQUARE HOLE
RIVET, NYLON
LABEL, CAUTION (US,CND)
1-580-375-41
1-694-541-11
1-694-541-21
1-694-541-11
1-694-541-21
INLET 3P
TERMINAL BOARD (SP)(EXCEPT US,CND)
TERMINAL BOARD (SP)(US,CND)
TERMINAL BOARD (SP)(EXCEPT US,CND)
TERMINAL BOARD (SP)(US,CND)
16
Ref. No.
Part No.
Description
51
52
53
54
* 55
4-217-750-01
4-217-782-01
X-4951-184-1
X-4951-185-1
4-880-426-00
PANEL, FRONT
ESCUTCHEON (POWER BUTTON)
BUTTON ASSY, POWER
BRACKET (POWER BUTTON) ASSY
SPRING, COMPRESSION
56
57
58
59
60
4-862-338-00
4-217-777-01
4-217-771-01
4-217-772-01
4-217-778-01
RING, STOPPER
PLATE (FRONT), INDICATION
PLATE (HALF MIRROR),INDICATION
PLATE (MASK), INDICATION (BLACK)
PLATE (FILTER), INDICATION (MILKY WHITE)
61
4-218-442-01 PLATE (BASE 2), INDICATION (WHITE)
16
Remark
Ref. No.
Part No.
Description
62
63
64
65
4-221-068-01
4-218-441-01
4-217-779-01
1-673-334-11
PLATE (SPACER), INDICATION
PLATE (FILTER 2), INDICATION (MILKY WHITE)
PLATE (BASE), INDICATION
LED BOARD
Remark
66
67
68
69
70
4-217-769-01
4-217-755-01
1-673-336-11
4-218-443-01
X-4942-178-1
REINFORCEMENT (F)
PANEL, SUB
AC-SW BOARD
BRACKET (FOOT)
FOOT ASSY
71
72
4-911-049-21 SCREW (3X8)
4-222-564-01 PLATE (FILTER C), INDICATION (ORANGE)
5-3. HEAT SINK SECTION
#5
not supplied
#5
#3
104
#5
#5
not supplied
#3
105
Q304
#5
Q305
#5
103
Q312
Q313
103
102
102
Q306
#5
Q307
Q308
Q309
Q310 101
Q311
101
103
#3
104
108
not supplied
103
107
TH301
101
Q406
101 Q407
Q408
Q409
#4
Q405
102
103
Q404
#5
Q410
Q411
Q412
103
103
#4
not supplied
TH401
Q413
106
not supplied
Ref. No.
Part No.
Description
Remark
101
102
103
104
105
X-4952-038-1
X-4944-262-1
4-217-766-01
4-217-760-01
4-217-751-01
+B 3X16 (CU) ASSY
SCREW(3X8)ASSY, BARREL W +BVTT
BOSS
FRAME (F/R)
HEAT SINK (L)
106
107
107
108
108
4-217-752-01
A-4426-211-A
A-4426-215-A
A-4426-212-A
A-4426-216-A
HEAT SINK (R)
MAIN-L BAORD, COMPLETE (US,CND)
MAIN-L BOARD, COMPLETE (EXCEPT US,CND)
MAIN-R BOARD, COMPLETE (US,CND)
MAIN-R BOARD, COMPLETE (EXCEPT US,CND)
Q304
Q305
Q306
Q307
Q308
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
Q309
8-729-018-13 TRANSISTOR 2SJ201A-Y
Ref. No.
Part No.
Description
Q310
Q311
Q312
Q313
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
Q404
Q405
Q406
Q407
Q408
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
Q409
Q410
Q411
Q412
Q413
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TRANSISTOR 2SK1530A-Y
TRANSISTOR 2SJ201A-Y
TH301
TH401
1-576-080-11 THERMOSTAT
1-576-080-11 THERMOSTAT
Remark
17
5-4. BOTTOM PLATE AND FRAME SECTION
C553
• Lead wires are not supplied.
Supplied with C552
C552
C503
Supplied with
C502
#7
162
#7
not supplied
Supplied with C553
#7
Supplied with C503
#7
T1
C502
#3
#3
162
162
156
156
161
#10
156
165
156
152
162
156
158
156
156
not supplied
#10
163
158
#5
156
163
#10
#8
#10
165
156
#11
#11
#5
159
#11
#11
157
160
156
156
not supplied
157
160
154
153
155
151
#5
164
#6
#6
152
#5
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Ref. No.
Part No.
Description
151
152
153
154
155
4-217-754-01
4-217-760-01
4-217-761-01
4-217-762-01
3-655-653-21
PLATE, BOTTOM
FRAME (F/R)
FRAME (L)
FRAME (R)
BAND (TAITON), BINDING
* 156
* 157
158
159
159
4-931-964-01
1-641-950-11
4-217-763-01
A-4426-214-A
A-4426-218-A
SCREW (M4X6)
BOTTOM LID BOARD
BRACKET (PC-PS)
AC/PS BOARD, COMPLETE (US,CND)
AC/PS BOARD, COMPLETE (EXCEPT US,CND)
160
18
X-4944-262-1 SCREW(3X8)ASSY, BARREL W +BVTT
Remark
Ref. No.
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Part No.
Description
161
162
163
164
1-673-333-11
4-965-658-01
4-218-396-01
3-831-441-11
PS-B BOARD
SCREW (4X16)
HOLDER (BASE C)
CUSHION (F)
Remark
* 165
C502
C503
C552
C553
4-931-964-11
1-128-999-11
1-128-999-11
1-128-999-11
1-128-999-11
SCREW (M4X8)
CAP, ELECT 27000MF
CAP, ELECT 27000MF
CAP, ELECT 27000MF
CAP, ELECT 27000MF
! T1
! T1
1-433-767-11 TRANSFORMER, POWER (US,CND)
1-433-768-11 TRANSFORMER, POWER (EXCEPT US,CND)
SECTION 6
ELECTRICAL PARTS LIST
AC-SW
AC/PS
Note:
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
• Due to standardization, replacements in the parts list
may be different from the parts specified in the
diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Description
Remark
1-673-336-11 AC-SW BOARD
**********
< CAPACITOR >
C1
1-113-920-11 CERAMIC
0.0022uF 20%
250V
< SWITCH >
S1
1-771-187-11 SWITCH, AC POWER (U)
**************************************************************
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• CAPACITORS
uF : µ F
• COILS
uH : µ H
• Abbreviation
CND : Canadian model
Ref. No.
Part No.
Description
CN604
CN654
* CN701
* CN702
1-691-765-11
1-691-765-31
1-564-506-11
1-564-506-11
PLUG (MICRO CONNECTOR) 3P
PLUG (MICRO CONNECTOR) 3P
PLUG, CONNECTOR 3P
PLUG, CONNECTOR 3P
* CN751
* CN801
CN802
CN852
CN901
1-564-506-11
1-564-506-11
1-691-766-11
1-691-766-31
1-691-768-11
PLUG, CONNECTOR 3P
PLUG, CONNECTOR 3P
PLUG (MICRO CONNECTOR) 4P
PLUG (MICRO CONNECTOR) 4P
PLUG (MICRO CONNECTOR) 6P
CN902
Remark
1-691-768-11 PLUG (MICRO CONNECTOR) 6P
< DIODE >
A-4426-214-A AC/PS BOARD, COMPLETE (US,CND)
**********************
A-4426-218-A AC/PS BOARD, COMPLETE (EXCEPT US, CND)
**********************
1-533-798-11 HOLDER, FUSE
1-535-476-11 TERMINAL
< CAPACITOR >
C2
C5
C501
C551
C601
1-113-920-11
1-119-800-11
1-136-880-11
1-136-880-11
1-136-960-11
CERAMIC
ELECT
FILM
FILM
FILM
0.0022uF
100uF
2.2uF
2.2uF
0.1uF
20%
20%
10%
10%
10%
250V
25V
160V
160V
160V
C603
C604
C651
C653
C654
1-131-657-11
1-131-657-11
1-136-960-11
1-131-657-11
1-131-657-11
CAPACITOR
CAPACITOR
FILM
CAPACITOR
CAPACITOR
1500uF
1500uF
0.1uF
1500uF
1500uF
20%
20%
10%
20%
20%
80V
80V
160V
80V
80V
C701
C702
C751
C752
C801
1-126-024-11
1-126-029-11
1-126-024-11
1-126-029-11
1-104-993-11
ELECT
ELECT
ELECT
ELECT
FILM
220uF
3200uF
220uF
3200uF
0.01uF
20%
20%
20%
20%
5%
25V
25V
25V
25V
200V
C802
C803
C804
C805
C901
1-119-823-11
1-119-815-21
1-119-810-11
1-119-814-21
1-119-830-11
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
2200uF
100uF
1000uF
330uF
20%
20%
20%
20%
20%
50V
35V
35V
35V
35V
C902
C903
1-119-823-11 ELECT
1-119-823-11 ELECT
4.7uF
4.7uF
20%
20%
50V
50V
D1
D2
D3
D501
D551
8-719-024-99
8-719-024-99
8-719-024-99
8-719-072-90
8-719-072-90
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
PB302F
PB302F
D601
D602
D651
D652
D701
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-934-64
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
HZS9C2LT2
D702
D751
D752
D801
D802
8-719-934-64
8-719-934-64
8-719-934-64
8-719-024-99
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
HZS9C2LT2
HZS9C2LT2
HZS9C2LT2
11ES2-NTA2B
11ES2-NTA2B
D803
D804
D805
D806
D901
8-719-024-99
8-719-024-99
8-719-024-99
8-719-935-20
8-719-024-99
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
HZS27-1LT2
11ES2-NTA2B
D902
8-719-024-99 DIODE 11ES2-NTA2B
< FUSE >
! F1
! F2
! F2
1-532-350-11 FUSE, TIME-LAG (T4AL/250V)(EXCEPT US,CND)
1-576-379-11 FUSE (15A/250V)(US,CND)
1-532-350-11 FUSE, TIME-LAG (T4AL/250V)(EXCEPT US,CND)
< TRANSISTOR >
< CONNECTOR >
* CN601
1-766-920-11 PIN, CONNECTOR 4P
Q1
Q701
Q702
Q751
Q752
8-729-281-54
8-729-202-67
8-749-010-25
8-729-202-67
8-749-010-26
TRANSISTOR
2SC1815-BL
TRANSISTOR
2SK246-GR3
IC MN2488-OPY-M
TRANSISTOR
2SK246-GR3
IC MP1620-OPY-M
19
AC/PS
Ref. No.
INPUT
Part No.
Description
Q801
Q901
Q902
Q903
Q904
8-729-018-60
8-729-201-53
8-729-422-96
8-729-201-53
8-729-900-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2012-LC
2SA1015-GR
UN4113-TA
2SA1015-GR
UN4211-TA
Remark
Q905
8-729-281-54 TRANSISTOR
2SC1815-BL
Ref. No.
R906
R907
R908
R909
Part No.
Description
1-259-292-11
1-259-292-11
1-259-207-21
1-249-887-11
CARBON
CARBON
CARBON
CARBON
Remark
330
330
47K
33
5%
5%
5%
5%
1/2W
1/2W
1/4W
1/4W
< RELAY >
RY1
RY2
< RESISTOR >
! R1
1-217-780-11 FUSIBLE
1
! R1
1-217-781-11 FUSIBLE
2.2
! R2
1-217-780-11 FUSIBLE
1
! R2
1-217-781-11 FUSIBLE
2.2
! R3
1-217-780-11 FUSIBLE
1
! R3
1-217-781-11 FUSIBLE
2.2
! R4
1-217-780-11 FUSIBLE
1
! R4
1-217-781-11 FUSIBLE
2.2
! R5
1-217-780-11 FUSIBLE
1
! R5
1-217-781-11 FUSIBLE
2.2
! R6
1-217-780-11 FUSIBLE
1
! R6
1-217-781-11 FUSIBLE
2.2
! R7
1-217-780-11 FUSIBLE
1
! R7
1-217-781-11 FUSIBLE
2.2
! R8
1-217-780-11 FUSIBLE
1
! R8
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
1-515-999-11 RELAY, POWER
1-515-999-11 RELAY, POWER
5%
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
5%
5W
F
(EXCEPT US, CND)
5%
5W
F
(US,CND)
1-217-781-11 FUSIBLE
2.2
5%
5W
F
(EXCEPT US, CND)
5%
1/2W
5%
1/2W
5%
1/4W
5%
1/4W
R9
R10
R11
R12
1-249-645-11
1-249-645-11
1-259-207-21
1-259-183-11
CARBON
CARBON
CARBON
CARBON
68
68
47K
4.7K
R13
! R501
! R551
! R701
R702
1-259-183-11
1-202-937-41
1-202-937-41
1-219-022-11
1-259-191-21
CARBON
FUSIBLE
FUSIBLE
FUSIBLE
CARBON
4.7K
10
10
100
10K
5%
5%
5%
5%
5%
1/4W
1/2W
1/2W
1/2W
1/4W
R703
! R751
R752
R753
! R803
1-259-167-21
1-219-022-11
1-259-191-21
1-259-167-21
1-202-937-31
CARBON
FUSIBLE
CARBON
CARBON
FUSIBLE
1K
100
10K
1K
10
5%
5%
5%
5%
5%
1/4W
1/2W
1/4W
1/4W
1/2W
R804
R901
R902
R903
R904
1-259-179-21
1-259-183-11
1-259-195-11
1-259-183-11
1-259-199-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
4.7K
15K
4.7K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< TRANSFORMER >
! T601
1-427-648-11 TRANSFORMER (CHOKE)
< THERMISTOR >
TH801
TH802
1-801-829-11 THERMISTOR, POSITIVE
1-801-829-11 THERMISTOR, POSITIVE
**************************************************************
1-673-331-11 INPUT BOARD
**********
4-946-336-01 BRACKET (GROUND)
< CAPACITOR >
C106
C111
C112
C113
C206
1-125-850-21
1-136-165-00
1-136-165-00
1-136-165-00
1-125-850-21
FILM
FILM
FILM
FILM
FILM
C213
1-136-165-00 FILM
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
0.1uF
5%
50V
< CONNECTOR >
* CN101
* CN201
1-564-507-11 PLUG, CONNECTOR 4P
1-564-507-11 PLUG, CONNECTOR 4P
< JACK >
CNJ101 1-766-803-11 CONNECTOR (CANON)(BALANCE L)
CNJ201 1-766-803-11 CONNECTOR (CANON)(BALANCE R)
< DIODE >
D101
D102
D103
D203
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
1SS119-25
1SS119-25
1SS119-25
1SS119-25
< JACK >
J101
1-785-547-11 JACK, PIN (UNBALANCE 1,2 L/R)
< TRANSISTOR >
Q101
Q102
Q103
Q111
Q112
8-729-422-57
8-729-422-57
8-729-422-57
8-729-900-80
8-729-900-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN4111
UN4111
UN4111
UN4211-TA
UN4211-TA
Q113
Q203
8-729-900-80 TRANSISTOR
8-729-422-57 TRANSISTOR
UN4211-TA
UN4111
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
20
220PF
0.1uF
0.1uF
0.1uF
220PF
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
INPUT
Ref. No.
Part No.
Description
Remark
Ref. No.
< RESISTOR >
1-249-995-11
1-249-995-11
1-249-995-11
1-249-995-11
1-249-210-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1M
1M
1M
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/3W
R111
R112
R113
R120
R201
1-259-404-11
1-259-404-11
1-259-404-11
1-259-452-11
1-249-995-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
10K
1M
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/4W
R202
R203
R204
R206
R213
1-249-995-11
1-249-995-11
1-249-995-11
1-249-210-11
1-259-404-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1M
1M
1K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/3W
1/6W
< RELAY >
1-755-062-11
1-755-062-11
1-755-062-11
1-755-062-11
MAIN-L
Description
Remark
A-4426-211-A MAIN-L BOARD, COMPLETE (US,CND)
******************************
R101
R102
R103
R104
R106
RY101
RY102
RY103
RY203
Part No.
LED
RELAY
RELAY
RELAY
RELAY
A-4426-215-A MAIN-L BOARD, COMPLETE (EXCEPT US, CND)
**************************************
7-682-148-15 SCREW, TR
< CAPACITOR >
C300
C301
C305
C306
C307
1-125-850-21
1-125-850-21
1-117-775-31
1-117-775-31
1-127-741-41
FILM
FILM
FILM
FILM
ELECT
220PF
220PF
0.1uF
0.1uF
0.047uF
5%
5%
10%
10%
10%
50V
50V
250V
250V
250V
C308
C309
C310
C311
C314
1-128-971-11
1-128-971-11
1-117-775-31
1-117-775-31
1-117-775-31
ELECT
ELECT
FILM
FILM
FILM
220uF
220uF
0.1uF
0.1uF
0.1uF
20%
20%
10%
10%
10%
50V
50V
250V
250V
250V
C315
C316
C317
C318
C319
1-128-971-11
1-110-512-51
1-110-512-51
1-125-845-21
1-125-845-21
ELECT
FILM
FILM
FILM
FILM
220uF
1uF
1uF
47PF
47PF
20%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C321
C322
C323
C324
C327
1-127-741-41
1-127-741-41
1-117-775-31
1-117-775-31
1-119-823-11
ELECT
ELECT
FILM
FILM
ELECT
0.047uF
0.047uF
0.1uF
0.1uF
4.7uF
10%
10%
10%
10%
20%
250V
250V
250V
250V
50V
C328
C329
C330
C331
C332
1-125-850-21
1-136-157-00
1-110-394-21
1-136-157-00
1-136-157-00
FILM
FILM
ELECT
FILM
FILM
220PF
0.022uF
220uF
0.022uF
0.022uF
5%
5%
20%
5%
5%
50V
50V
63V
50V
50V
C333
C334
C337
C338
1-119-800-11
1-119-800-11
1-126-026-11
1-126-026-11
ELECT
ELECT
ELECT
ELECT
100uF
100uF
470uF
470uF
20%
20%
20%
20%
25V
25V
25V
25V
< SWITCH >
S101
1-771-565-11 SWITCH, ROTARY (INPUT SELECTOR)
**************************************************************
1-673-334-11 LED BOARD
********
< CAPACITOR >
C951
C952
C960
C961
C962
1-136-157-00
1-136-157-00
1-136-157-00
1-136-157-00
1-136-157-00
FILM
FILM
FILM
FILM
FILM
0.022uF
0.022uF
0.022uF
0.022uF
0.022uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C963
1-136-157-00 FILM
0.022uF
5%
50V
< CONNECTOR >
< DIODE >
* CN306
D951
D952
D953
D954
D955
8-719-069-45
8-719-069-45
8-719-069-45
8-719-069-45
8-719-075-81
DIODE
DIODE
DIODE
DIODE
DIODE
SELU5E23C-TP15
SELU5E23C-TP15
SELU5E23C-TP15
SELU5E23C-TP15
SEL1610C-TP8
D960
D961
D962
D963
8-719-985-41
8-719-075-82
8-719-075-82
8-719-075-82
DIODE
DIODE
DIODE
DIODE
HZS2CLL
SELU1810CXM-TP8 (UNBALANCE 1)
SELU1810CXM-TP8 (UNBALANCE 2)
SELU1810CXM-TP8 (BALANCE)
1-564-505-11 PLUG, CONNECTOR 2P
< COMPOSITION CIRCUIT BLOCK >
CP301
1-418-105-11 AMPLIFIER, UNIT
< DIODE >
< RESISTOR >
R952
R971
1-259-292-11 CARBON
1-259-416-11 CARBON
330
330
5%
5%
1/2W
1/6W
D301
D302
D303
D304
D305
8-719-310-61
8-719-300-04
8-719-300-04
8-719-300-04
8-719-300-04
DIODE
DIODE
DIODE
DIODE
DIODE
SEL1510C-D
SV-04
SV-04
SV-04
SV-04
D306
D307
D308
8-719-024-99 DIODE 11ES2-NTA2B
8-719-024-99 DIODE 11ES2-NTA2B
8-719-024-99 DIODE 11ES2-NTA2B
**************************************************************
< IC >
IC301
8-759-579-36 IC OPA2132P
21
MAIN-L
Ref. No.
Part No.
Ref. No.
Part No.
< BUS BAR >
Description
Remark
! R326
1-205-647-11 CEMENTED
0.22
5%
5W
JWH301 1-569-232-11 BAR, BUS
JWH302 1-770-108-11 BAR, BUS 7P
* JWH303 1-566-940-11 BUS BAR 6P
! R327
! R328
! R329
! R330
! R331
1-205-647-11
1-205-647-11
1-205-647-11
1-205-647-11
1-205-647-11
CEMENTED
CEMENTED
CEMENTED
CEMENTED
CEMENTED
0.22
0.22
0.22
0.22
0.22
5%
5%
5%
5%
5%
5W
5W
5W
5W
5W
! R332
! R333
! R334
! R335
! R336
1-205-647-11
1-205-647-11
1-205-647-11
1-202-937-41
1-202-937-41
CEMENTED
CEMENTED
CEMENTED
FUSIBLE
FUSIBLE
0.22
0.22
0.22
10
10
5%
5%
5%
5%
5%
5W
5W
5W
1/2W
1/2W
! R337
! R338
R339
! R340
R341
1-202-937-41
1-202-937-41
1-259-749-61
1-202-954-11
1-259-191-21
FUSIBLE
FUSIBLE
CARBON
FUSIBLE
CARBON
10
10
10
470
10K
5%
5%
2%
5%
5%
1/2W
1/2W
2W
1/2W
1/4W
R342
R343
R344
R345
R346
1-249-959-11
1-259-175-11
1-259-171-21
1-249-959-11
1-249-883-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
2.2K
1.5K
33K
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R347
R348
R349
R350
R351
1-259-227-11
1-259-223-11
1-249-953-11
1-259-207-21
1-259-219-11
CARBON
CARBON
CARBON
CARBON
CARBON
330K
220K
18K
47K
150K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R352
R353
! R355
! R356
R357
1-249-945-11
1-214-945-00
1-202-937-41
1-202-937-41
1-259-167-21
CARBON
METAL
FUSIBLE
FUSIBLE
CARBON
8.2K
2.2M
10
10
1K
5%
1%
5%
5%
5%
1/4W
1/2W
1/2W
1/2W
1/4W
R358
R359
R360
R361
R362
1-249-945-11
1-249-945-11
1-259-111-11
1-259-111-11
1-249-210-11
CARBON
CARBON
CARBON
CARBON
CARBON
8.2K
8.2K
4.7
4.7
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/3W
< COIL >
* L301
1-428-071-11 COIL, AIR-CORE
< IC LINK >
PS301
8-759-111-68 IC UPC1237HA
< TRANSISTOR >
Q301
Q302
Q303
Q304
Q305
8-729-281-53
8-729-018-19
8-729-018-21
8-729-018-11
8-729-018-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1815-GR
2SK2013-Y
2SJ313-Y
2SK1530A-Y
2SJ201A-Y
Q306
Q307
Q308
Q309
Q310
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
Q311
Q312
Q313
Q314
Q315
8-729-018-13
8-729-018-11
8-729-018-13
8-729-140-84
8-729-140-82
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SC1841-PAFAEA
2SA988-PAFAEA
Q316
Q317
Q318
Q319
8-729-201-53
8-729-281-53
8-729-281-53
8-729-201-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015-GR
2SC1815-GR
2SC1815-GR
2SA1015-GR
< RESISTOR >
R300
R301
R302
R303
R304
1-259-525-11
1-259-595-61
1-259-595-61
1-259-668-61
1-259-668-61
CARBON
CARBON
CARBON
CARBON
CARBON
56
47K
47K
470
470
2%
1%
1%
2%
2%
1W
1/2W
1/2W
1W
1W
R305
R306
R307
R308
! R309
1-259-668-61
1-259-525-11
1-259-183-11
1-259-171-21
1-202-954-41
CARBON
CARBON
CARBON
CARBON
FUSIBLE
470
56
4.7K
1.5K
470
2%
2%
5%
5%
5%
1W
1W
1/4W
1/4W
1/2W
! R310
! R312
! R313
! R315
! R316
1-202-954-41
1-202-951-41
1-202-951-41
1-219-185-11
1-219-185-11
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
470
150
150
47
47
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
! R317
! R318
! R319
! R320
! R321
1-219-185-11
1-219-185-11
1-219-185-11
1-219-185-11
1-219-185-11
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
47
47
47
47
47
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
! R322
! R323
! R324
! R325
1-219-185-11
1-219-185-11
1-219-185-11
1-205-647-11
FUSIBLE
FUSIBLE
FUSIBLE
CEMENTED
47
47
47
0.22
5%
5%
5%
5%
1/2W
1/2W
1/2W
5W
Description
Remark
< VARIABLE RESISTOR >
RV301
1-224-489-11 RES, ADJ, METAL FILM 2.2K (BIAS L)
< RELAY >
RY301
RY302
1-755-310-11 RELAY
1-755-310-11 RELAY
< TEST PIN >
*
*
*
*
*
TP301
TP302
TP303
TP304
TP305
* TP306
* TP307
3-657-235-00
3-657-235-00
3-657-235-00
3-657-235-00
3-657-235-00
POINT, TEST
POINT, TEST
POINT, TEST
POINT, TEST
POINT, TEST
3-657-235-00 POINT, TEST
3-657-235-00 POINT, TEST
**************************************************************
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
22
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
MAIN-R
Ref. No.
Part No.
Description
Ref. No.
Remark
Part No.
A-4426-212-A MAIN-R BOARD, COMPLETE (US,CND)
******************************
Remark
< BUS BAR >
A-4426-216-A MAIN-R BOARD, COMPLETE (EXCEPT US, CND)
**************************************
JWH401 1-569-232-11 BAR, BUS
JWH402 1-770-108-11 BAR, BUS 7P
* JWH403 1-566-940-11 BUS BAR 6P
3-657-235-00 POINT, TEST
7-682-148-15 SCREW, TR
*
Description
< COIL >
* L401
1-428-071-11 COIL, AIR-CORE
< CAPACITOR >
< IC LINK >
C400
C401
C405
C406
C407
1-125-850-21
1-125-850-21
1-117-775-31
1-117-775-31
1-127-741-41
FILM
FILM
FILM
FILM
ELECT
220PF
220PF
0.1uF
0.1uF
0.047uF
5%
5%
10%
10%
10%
50V
50V
250V
250V
250V
C408
C409
C410
C411
C414
1-128-971-11
1-128-971-11
1-117-775-31
1-117-775-31
1-117-775-31
ELECT
ELECT
FILM
FILM
FILM
220uF
220uF
0.1uF
0.1uF
0.1uF
20%
20%
10%
10%
10%
50V
50V
250V
250V
250V
C415
C416
C417
C418
C419
1-128-971-11
1-110-512-51
1-110-512-51
1-125-845-21
1-125-845-21
ELECT
FILM
FILM
FILM
FILM
220uF
1uF
1uF
47PF
47PF
20%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C421
C422
C423
C424
C427
1-127-741-41
1-127-741-41
1-117-775-31
1-117-775-31
1-119-823-11
ELECT
ELECT
FILM
FILM
ELECT
0.047uF
0.047uF
0.1uF
0.1uF
4.7uF
10%
10%
10%
10%
20%
250V
250V
250V
250V
50V
C428
C429
C430
C431
C432
1-125-850-21
1-136-157-00
1-110-394-21
1-136-157-00
1-136-157-00
FILM
FILM
ELECT
FILM
FILM
220PF
0.022uF
220uF
0.022uF
0.022uF
5%
5%
20%
5%
5%
50V
50V
63V
50V
50V
C433
C434
C437
C438
1-119-800-11
1-119-800-11
1-126-026-11
1-126-026-11
ELECT
ELECT
ELECT
ELECT
100uF
100uF
470uF
470uF
20%
20%
20%
20%
25V
25V
25V
25V
PS401
8-759-111-68 IC UPC1237HA
< TRANSISTOR >
Q401
Q402
Q403
Q404
Q405
8-729-281-53
8-729-018-19
8-729-018-21
8-729-018-11
8-729-018-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1815-GR
2SK2013-Y
2SJ313-Y
2SK1530A-Y
2SJ201A-Y
Q406
Q407
Q408
Q409
Q410
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
Q411
Q412
Q413
Q414
Q415
8-729-018-13
8-729-018-11
8-729-018-13
8-729-140-84
8-729-140-82
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SC1841-PAFAEA
2SA988-PAFAEA
Q416
Q417
Q418
Q419
8-729-201-53
8-729-281-53
8-729-281-53
8-729-201-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015-GR
2SC1815-GR
2SC1815-GR
2SA1015TP-GR
< RESISTOR >
R400
R401
R402
R403
R404
1-259-525-11
1-259-595-61
1-259-595-61
1-259-668-61
1-259-668-61
CARBON
CARBON
CARBON
CARBON
CARBON
56
47K
47K
470
470
2%
1%
1%
2%
2%
1W
1/2W
1/2W
1W
1W
R405
R406
R407
R408
! R409
1-259-668-61
1-259-525-11
1-259-183-11
1-259-171-21
1-202-954-41
CARBON
CARBON
CARBON
CARBON
FUSIBLE
470
56
4.7K
1.5K
470
2%
2%
5%
5%
5%
1W
1W
1/4W
1/4W
1/2W
! R410
! R412
! R413
! R415
! R416
1-202-954-41
1-202-951-41
1-202-951-41
1-219-185-11
1-219-185-11
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
470
150
150
47
47
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
! R417
! R418
! R419
! R420
! R421
1-219-185-11
1-219-185-11
1-219-185-11
1-219-185-11
1-219-185-11
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
47
47
47
47
47
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
! R422
! R423
! R424
1-219-185-11 FUSIBLE
1-219-185-11 FUSIBLE
1-219-185-11 FUSIBLE
47
47
47
5%
5%
5%
1/2W
1/2W
1/2W
< CONNECTOR >
* CN406
1-564-505-11 PLUG, CONNECTOR 2P
< COMPOSITION CIRCUIT BLOCK >
CP401
1-418-105-11 AMPLIFIER, UNIT
< DIODE >
D401
D402
D403
D404
D405
8-719-310-61
8-719-300-04
8-719-300-04
8-719-300-04
8-719-300-04
DIODE
DIODE
DIODE
DIODE
DIODE
SEL1510C-D
SV-04
SV-04
SV-04
SV-04
D406
D407
D408
8-719-024-99 DIODE 11ES2-NTA2B
8-719-024-99 DIODE 11ES2-NTA2B
8-719-024-99 DIODE 11ES2-NTA2B
< IC >
IC401
8-759-579-36 IC OPA2132P
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
23
MAIN-R
PS-B
Ref. No.
Part No.
! R425
! R426
1-205-647-11 CEMENTED
1-205-647-11 CEMENTED
Description
0.22
0.22
5%
5%
5W
5W
! R427
! R428
! R429
! R430
! R431
1-205-647-11
1-205-647-11
1-205-647-11
1-205-647-11
1-205-647-11
CEMENTED
CEMENTED
CEMENTED
CEMENTED
CEMENTED
0.22
0.22
0.22
0.22
0.22
5%
5%
5%
5%
5%
5W
5W
5W
5W
5W
! R432
! R433
! R434
! R435
! R436
1-205-647-11
1-205-647-11
1-205-647-11
1-202-937-41
1-202-937-41
CEMENTED
CEMENTED
CEMENTED
FUSIBLE
FUSIBLE
0.22
0.22
0.22
10
10
5%
5%
5%
5%
5%
5W
5W
5W
1/2W
1/2W
! R437
! R438
! R439
! R440
R441
1-202-937-41
1-202-937-41
1-259-749-61
1-202-954-11
1-259-191-21
FUSIBLE
FUSIBLE
CARBON
FUSIBLE
CARBON
10
10
10
470
10K
5%
5%
2%
5%
5%
1/2W
1/2W
2W
1/2W
1/4W
R442
R443
R444
! R445
! R446
1-249-959-11
1-259-175-11
1-259-171-21
1-249-959-11
1-249-883-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
2.2K
1.5K
33K
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R447
R448
R449
R450
R451
1-259-227-11
1-259-223-11
1-249-953-11
1-259-207-21
1-259-219-11
CARBON
CARBON
CARBON
CARBON
CARBON
330K
220K
18K
47K
150K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R452
R453
R455
R456
R457
1-249-945-11
1-214-945-00
1-202-937-41
1-202-937-41
1-259-167-21
CARBON
METAL
FUSIBLE
FUSIBLE
CARBON
8.2K
2.2M
10
10
1K
5%
1%
5%
5%
5%
1/4W
1/2W
1/2W
1/2W
1/4W
R458
R459
R460
R461
R462
1-249-945-11
1-249-945-11
1-259-111-11
1-259-111-11
1-249-210-11
CARBON
CARBON
CARBON
CARBON
CARBON
8.2K
8.2K
4.7
4.7
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/3W
Ref. No.
Remark
Part No.
Description
Remark
C553
1-128-999-11 CAP, ELECT
27000MF 20%
80V
C554
1-117-775-31 FILM
0.1uF
250V
10%
< CONNECTOR >
CN504
CN554
CN603
1-564-320-00 PIN, CONNECTOR 2P
1-564-320-00 PIN, CONNECTOR 2P
1-691-765-11 PLUG (MICRO CONNECTOR) 3P
< BUS BAR >
* JWH502
JWH503
JWH504
* JWH552
JWH553
1-569-135-11
1-566-940-21
1-566-940-21
1-569-135-11
1-566-940-21
BAR, BUS 4P
BUS BAR 3P
BUS BAR 3P
BAR, BUS 4P
BUS BAR 3P
JWH554 1-566-940-21 BUS BAR 3P
**************************************************************
MISCELLANEOUS
*************
< VARIABLE RESISTOR >
RV401
1-224-489-11 RES, ADJ, METAL FILM 2.2K (BIAS R)
< RELAY >
RY401
RY402
1-755-310-11 RELAY
1-755-310-11 RELAY
C502
C503
C552
C553
CNJ1
1-128-999-11
1-128-999-11
1-128-999-11
1-128-999-11
1-580-375-41
CAP, ELECT 27000uF
CAP, ELECT 27000uF
CAP, ELECT 27000uF
CAP, ELECT 27000uF
INLET 3P
20%
20%
20%
20%
80V
80V
80V
80V
Q304
Q305
Q306
Q307
Q308
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
Q309
Q310
Q311
Q312
Q313
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
Q404
Q405
Q406
Q407
Q408
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
Q409
Q410
Q411
Q412
Q413
8-729-018-13
8-729-018-11
8-729-018-13
8-729-018-11
8-729-018-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
2SK1530A-Y
2SJ201A-Y
1-433-767-11
1-433-768-11
1-694-541-11
1-694-541-21
1-694-541-11
TRANSFORMER, POWER (US,CND)
TRANSFORMER, POWER (EXCEPT US,CND)
TERMINAL BOARD (SP)(EXCEPT US,CND)
TERMINAL BOARD (SP)(US,CND)
TERMINAL BOARD (SP)(EXCEPT US,CND)
**************************************************************
! T1
! T1
TB351
TB351
TB451
1-673-333-11 PS-B BOARD
*********
3-346-266-21 PLATE, GROUND
4-916-791-01 PLATE, GROUND, 5P
7-682-148-15 SCREW, TR
*
*
TB451
TH301
TH401
< CAPACITOR >
C502
C503
C504
C552
1-128-999-11
1-128-999-11
1-117-775-31
1-128-999-11
CAP, ELECT
CAP, ELECT
FILM
CAP, ELECT
27000MF 20%
27000MF 20%
0.1uF
10%
27000MF
80V
80V
250V
80V
1-694-541-21 TERMINAL BOARD (SP)(US,CND)
1-576-080-11 THERMOSTAT
1-576-080-11 THERMOSTAT
**************************************************************
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
24
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
Remark
ACCESSORIES & PACKING MATERIALS
*******************************
1-551-631-22 CORD, POWER (EXCEPT US,CND)
1-551-812-11 CORD, POWER (US,CND)
3-866-957-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
3-866-957-21 MANUAL, INSTRUCTION (GERMAN,SPANISH,
DUTCH,SWEDISH,ITALIAN,PORTUGUESE)(EXCEPT US,CND)
4-396-077-01 JOINT
!
!
*
**************************************************************
*************
HARDWARE LIST
*************
#1
#2
#3
#4
#5
7-682-962-01
7-683-438-04
7-682-561-09
7-682-546-09
7-682-548-09
SCREW +PSW4X10
BOLT, HEXAGON SOCKET 5X16
SCREW +B 4X8
SCREW +B 3X5
SCREW +B 3X8
#6
#7
#8
#9
#10
7-682-562-09
7-682-563-09
7-682-148-15
7-682-568-09
7-684-024-04
SCREW +B 4X10
SCREW +B 4X12
SCREW, TR
SCREW +B 4X30
N 4, TYPE 2
#11
7-685-870-01 SCREW +BVTT 3X5 (S)
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
25
TA-N1
9-928-913-11
Sony Corporation
Home Audio Company
26
99G0989-1
Printed in Japan © 1999. 7
Published by Quality Assurance Dept.