Download OPERATING INSTRUCTIONS

GAS CONTINUOUS FLOW
WATER HEATERS
OPERATING
INSTRUCTIONS
FOR MODELS
16NG50-6/16LP50-6, 16NG60-6/16LP60-6,
20NG50-6/20LP50-6, 20NG60-6/20LP60-6,
26NG50-6/26LP50-6, 26NG60-6/26LP60-6
2
OPERATING INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
1. Do not hang washing or other
materials adjacent to the unit.
'RQRWVWRUHÀDPPDEOH
materials within 2 metres
of the unit.
'RQRWWRXFKWKHÀXHRXWOHWRIWKHXQLW
during or immediately after operation.
4. If any gas smell comes from the unit,
GRQRWXVHQDNHGÀDPHVWRWHVWIRUJDVOHDNV
Turn off the gas supply and power and
FRQWDFW\RXUSOXPEHURU5HHFH&XVWRPHU
Care on 1800 080 055.
CLOSE
No Fire
Prohibited
5. If a power failure occurs the remote controls will not function and the Thermann unit
will not supply hot water until power is restored.
OPERATING INSTRUCTIONS
3
IMPORTANT SAFETY INSTRUCTIONS
MEASURES TO BE TAKEN DURING
ELECTRICAL STORMS
3RZHUVXUJHVFDXVHGE\OLJKWQLQJFDQGDPDJHWKHHOHFWURQLFSDUWV7KHUHIRUHWXUQRII
the main power during electrical storms
DO NOT INSTALL INDOORS
Danger
0D\FDXVHR[\JHQGH¿FLHQF\DFFLGHQWRULQFRPSOHWH
FRPEXVWLRQ
This unit is designed for outdoor installation. Never install
LQGRRUV,WZLOOEHH[WUHPHO\GDQJHURXVEHFDXVHLWZLOOFDXVH
R[\JHQGH¿FLHQF\DQGLQFRPSOHWHFRPEXVWLRQ
,IWKHXQLWKDVEHHQLQVWDOOHGLQGRRUVWXUQRIIWKHJDVVXSSO\DQG
FRQWDFW\RXUSOXPEHULPPHGLDWHO\
SECURE SERVICE SPACE
Make sure there is enough space around the unit for checking,
service and maintenance.
Check
4
OPERATING INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
DO NOT DISASSEMBLE, REPAIR OR MODIFY
Warning
'RQRWGLVDVVHPEOHRUPRGLI\WKHXQLWV$VWKLV
PD\FDXVH¿UHHOHFWULFVKRFNDQGRWKHUDFFLGHQWV
$OZD\VXVHDOLFHQVHGSOXPEHUIRULQVWDOODWLRQ
relocation or connection to solar units.
FLAMMABLE ITEMS
Warning
0D\FDXVH¿UHRUH[SORVLRQ
'RQRWSODFHDQ\ÀDPPDEOHLWHPVQHDUWKHXQLW
or use them around the unit.
FREEZE PREVENTION
This unit comes equipped with internal electric heaters that prevent the water inside
the unit from freezing.
7RHQDEOHWKLVIUHH]HSUHYHQWLRQV\VWHPWRRSHUDWHWKHUHPXVWEHDQHOHFWULFDO
power supply connected to the unit.
The freeze prevention devices will not operate if the electrical power source is not
connected.
The electric defrost heaters are installed inside the water heater only.
$OO([WHUQDO+RWDQG&ROGZDWHUVXSSO\SLSHVDQG¿WWLQJVFRQQHFWHGWR
WKHZDWHUKHDWHUVKRXOGEHSURSHUO\LQVXODWHG
WATER INLET PRESSURE
Maximum working water pressure is 1200kPa
CAUTION TO PREVENT SCALDING
&KHFNWKHZDWHUWHPSHUDWXUHE\KDQG
¿UVWEHIRUHXVLQJVKRZHU
Caution
OPERATING INSTRUCTIONS
5
IMPORTANT SAFETY INSTRUCTIONS
MEASURES TO BE TAKEN IN
CASE OF EMERGENCY
The procedure to follow in an emergency such as
HDUWKTXDNHÀRRGRU¿UHLV
Close
Close
1. Close all hot water taps in the house.
2. Close the gas valve and the main water valve.
3. Turn off the main power.**
,QFDVHRIJDVOHDNDJH¿UVWFORVHWKHJDVYDOYHWKHQZDLWIRUWKH
leaked gas to disperse then turn off the main power supply**
This appliance is not intended for use by persons (including children) with reduced physical,
sensory or mental capabilities, or lack of experience and knowledge, unless they have been
given supervision or instruction concerning use of the appliance by a person responsible for
their safety.
Children should be supervised to ensure that they do not play with the appliance.
ELECTRICAL CONNECTION
DANGER OF WET HANDS
Do not touch power plug with wet hands.
It can cause electric shock.
Caution
Warning
INSERT POWER PLUG FULLY
INTO POWERPOINT
Check that the power plug is clean and undamaged,
then fully insert into the power point.
Check
DO NOT PULL POWER CORD
'RQRWUHPRYHWKHSRZHUSOXJE\SXOOLQJWKHFRUG
DVLWPD\JHQHUDWHKHDWE\ZLUHEUHDNDJHDQGFDXVH
¿UH+ROGWKHSOXJZKHQUHPRYLQJWKHSRZHUFRUG
3URKLELWHG
DO NOT USE POWER CORD BUNDLED
1HYHUXVHSRZHUFRUGLQDEXQGOHGFRQGLWLRQ
,WPD\FDXVHKHDWJHQHUDWLRQDQG¿UH
3URKLELWHG
DO NOT REPLACE POWER CORD
,IWKHSRZHUVXSSO\FRUGLVGDPDJHGLWVKRXOGEHUHSODFHGE\DFRUGDYDLODEOH
IURP5((&(DJHQWV7KHSRZHUFRUGPXVWEHUHSODFHGE\DQDXWKRULVHGSHUVRQWR
prevent accidents.
6
OPERATING INSTRUCTIONS
REMOTE CONTROL
8SWRWKUHHUHPRWHFRQWUROVDUHDEOHWREHLQVWDOOHGZLWK\RXU7KHUPDQQXQLWIRU
complete control of your hot water.
3OHDVHQRWHXQLWVZLWKRXWUHPRWHFRQWUROZLOOEHVHWDWHLWKHUƒ&RUƒ&
WKHH[FHSWLRQLVLIWKHXQLWLVLQVWDOOHGDVDVRODUERRVWHU<RXUSOXPEHUZLOOKDYHVHW
WKHXQLWWRƒ&
YST-2807
8QLYHUVDO&RQWUROOHU
7KLVUHPRWHFRQWUROOHULVLQWHQGHGWREHXVHGLQWKHNLWFKHQODXQGU\URRPEDWKURRP
and ensuite.
High Temp. Indicator
Indicates the setting
temperature is higher
than 50゜
C.
Digital Monitor
Indicates the selected water temperature.
Error messages flash in the event of failure.
UP/DOWN Button
Increase or decrease the
desired water temperature.
In Use Indicator
Indicates that a hot water
tap is open.
ON Indicator
Indicates power is on to
the system.
PRIORITY Indicator
Indicates this controller has
priority control over by
controller.
ON/OFF Button
Power switch to operate
this remote controller.
PRIORITY Button
PRIORITY Button to set the
water temperature on this
remote controller.
7KHXQLWZLOOGHOLYHUWKHVHOHFWHGWHPSHUDWXUHDVIROORZV
Kitchen Controller:
DQGƒ&
Bathroom Controller:
ƒ&
2QO\IRUƒ&PRGHO
OPERATING INSTRUCTIONS
7
REMOTE CONTROL
Operation of Controller
3OHDVHUHDGWKHVHLQVWUXFWLRQVFDUHIXOO\EHIRUHXVLQJWKLVDSSOLDQFH
7XUQRQWKH212))EXWWRQ
7KHWHPSHUDWXUHGLVSOD\ZLOOUHDGƒ&
3. The priority indicator will illuminate.
6HOHFWKRWZDWHUWHPSHUDWXUHE\SXVKLQJ
or
EXWWRQRQWKHFRQWUROOHU
5. Turn on the hot water tap or shower. The ``In Use´´ indicator will illuminate
after a short delay.
This indicator will remain illuminated until the hot water tap or shower
is turned off.
7KHKRWZDWHUWHPSHUDWXUHFDQEHDOWHUHGDWDQ\WLPHGXULQJWKHRSHUDWLRQE\
or
EXWWRQ located on the controller.
pushing
Controller
Energy-saving Mode
If no data is adjusted within a period of approximately 5 minutes the display
EHFRPHVGLP7KLVLVHQHUJ\VDYLQJPRGHDQGQRWDIDLOXUH
8
OPERATING INSTRUCTIONS
REMOTE CONTROL
Priority Control (Change)
7KHWHPSHUDWXUHFDQRQO\EHFRQWUROOHGE\WKHUHPRWHFRQWUROOHUZKLFKKDVWKHSULRULW\
indication.
:KHQWKHSULRULW\EXWWRQLVWXUQHG21WKDWFRQWUROOHUWDNHVSULRULW\FRQWURORYHUWKH
WHPSHUDWXUHVHWWLQJV'XULQJKRWZDWHUVXSSO\RWKHUUHPRWHFRQWUROOHUVFDQQRWEH
WXUQHGRII
Whilst hot water outlets are open, transfer of ``priority´´ to other remote controllers is
QRWSRVVLEOH7KLVLVVDIHW\IHDWXUH
Warning
Do not turn off the remote controller or change the water temperature while someone is
bathing or washing. That may result in scalds or burns.
HINTS FOR USING REMOTE CONTROLS
FOR SAFETY AND ENERGY SAVINGS
6
HWWKHFRQWUROOHUWRDPD[LPXPRIƒ&IRUQRUPDOEDWKURRPXVHDQGWR
prevent small children from scalding.
)
RUNLWFKHQDQGODXQGU\XVHVHWWKH0$,1&21752/WRƒ&RUWKHGHVLUHG
temperature.
)
RUVKRZHULQJXVHVHWWLQJVEHWZHHQƒ&ƒ&DQGQRFROGZDWHUZLOO
EHQHHGHGWREHPL[HGDQGLIRWKHUKRWRUFROGZDWHUWDSVDUHXVHGWKH
WHPSHUDWXUHZLOOEHPDLQWDLQHG
:
KHQEDWKURRPUHPRWHFRQWUROOHULVWXUQHG21WKHWHPSHUDWXUHFDQEH
DGMXVWHGEHWZHHQƒ&ƒ&
8372ƒ&7+(7(03(5$785(:,//,1&5($6(%<ƒ&:,7+($&+
35(662)7+(83'2:1%8772167+(7(03(5$785(&$1%(
$'-867('&217,18286/<%<.((3,1*7+(%8772135(66('
%(7:((1ƒ&$1'ƒ&7+(7(03(5$785(,6&21752//('
%<ƒ&,1&5(0(1763/($6(127($%29(ƒ&6&$/',1*&$12&&85
WITHIN SECONDS.
OPERATING INSTRUCTIONS
9
FAULT MONITOR
When installed with remote controllers the THERMANN HOT WATER UNIT HAS A
SELF DIAGNOSING FUNCTION FOR FAULTS.
When the unit does not operate correctly an error code is displayed on the remote
FRQWURO7(03(5$785(',63/$<,1',&$725
7KHFDXVHRIWKHIDXOWFDQEHGHWHUPLQHGDIWHUFKHFNLQJWKHIDXOWQXPEHUVGLVSOD\RQ
the remote control display.
DISPLAY
PROBLEM
REMEDY
111
*$6%851(5)$,/672,*1,7(
&+(&.*$66833/<
121
/2662)&20%867,21
&+(&.*$66833/<$1'
PRESSURE
141
5(6,'8$/)/$0(6$)(7<
'(9,&(
CALL REECE CUSTOMER
CARE 1800 080 055
311, 321, 341
7+(50,6725:,5(%5($.$*(
CALL REECE CUSTOMER
CARE 1800 080 055
510, 511
*$69$/9()$,/85(
CALL REECE CUSTOMER
CARE 1800 080 055
611
&20%867,21)$1)$,/85(
CALL REECE CUSTOMER
CARE 1800 080 055
651
:$7(5)/2:&21752/9$/9(
FAILURE
CALL REECE CUSTOMER
CARE 1800 080 055
700, 731
3&%)$,/85(
CALL REECE CUSTOMER
CARE 1800 080 055
721
FALSE FLAME DETECTION
CALL REECE CUSTOMER
CARE 1800 080 055
735
CASCADE COMMUNICATION
FAILURE
CALL REECE CUSTOMER
CARE 1800 080 055
740, 750, 760
COMMUNICATION FAILURE
%(7:((15(027(&21752/6
$1'3&%
TURN OFF POWER AND
TURN ON AGAIN
MAINTENANCE
7KHVHXQLWVFDQEHFOHDQHGXVLQJZDUPVRDS\ZDWHUDQGDVRIWFORWK8QLWVKRXOGEH
kept free of insect infestations.
127('RQRWVSUD\FKHPLFDOLQVHFWLFLGHVGLUHFWO\LQWRRURQWRWKHXQLW
0DLQWDLQDOOSODQWJURZWKWRHQVXUHLWGRHVQRWHIIHFWWKHRSHUDWLRQRIWKHXQLWE\
EORFNLQJRULQWHUIHULQJZLWKDLULQWDNHRUÀXHWHUPLQDO
It is recommended the unit is checked for safe operation with an annual service.
6HUYLFLQJVKRXOGRQO\EHFDUULHGRXWE\DXWKRUL]HGSHUVRQQHOVXFKDVDOLFHQVHG
tradesman.
For servicing and spare parts information contact Reece Customer Care on 1800 080 055.
10
OPERATING INSTRUCTIONS
WARRANTY
Warranty Conditions
‡ 7KLVZDUUDQW\ZLOODSSO\RQO\XQGHUDOORIWKHIROORZLQJFRQGLWLRQV
‡ 7KHLWHPKDVEHHQLQVWDOOHGE\DOLFHQVHGSOXPEHU
‡ Failure is due to a fault in the manufacture of the product
‡ 3URRIRISXUFKDVHLQFOXGLQJWKHGDWHRISXUFKDVHLVSURYLGHG
‡ The installation of the product is in accordance with the instructions provided
‡ 7KLVZDUUDQW\GRHVQRWFRYHUSURGXFWVSXUFKDVHGDVDQH[GLVSOD\ZLWKRXWEHLQJ
IXOO\FKHFNHGDQGWHVWHGIRUVDOHE\WKHPDQXIDFWXUHU
This warranty does not include faults caused by:
‡ 8QVXLWDEOHRULPSURSHUXVH
‡ Incorrect installation or installation not in accordance with the instructions provided
‡ ,QVWDOODWLRQRUSDUWLQVWDOODWLRQE\WKHSXUFKDVHURUDQ\SHUVRQRWKHUWKDQD
/,&(16('3/80%(5RUWUDGHVSHUVRQOLFHQVHGWRLQVWDOOWKLVSURGXFW
‡ Normal wear and tear
‡ Inadequate or complete lack of maintenance
‡ &KHPLFDOHOHFWURFKHPLFDORUHOHFWULFDOLQÀXHQFHV
‡ +DUVKGHWHUJHQWVRUDEUDVLYHFOHDQHUVXVHGRQSURGXFW¿QLVKHV
EXCLUSIONS
7RWKHIXOOHVWH[WHQWSHUPLWWHGE\ODZ5HHFHH[FOXGHVDOOOLDELOLW\IRUGDPDJHRULQMXU\
to any person, damage to any property, and any indirect consequential or other loss or
damage.
CLAIM PROCEDURE
)RUDOOZDUUDQW\TXHULHVFXVWRPHUVDUHWRFRQWDFWWKHEUDQFKZKHUHWKHSURGXFWZDV
SXUFKDVHG7KHVHGHWDLOVFDQEHIRXQGRQ\RXUSXUFKDVHLQYRLFH
2XUJRRGVFRPHZLWKJXDUDQWHHVWKDWFDQQRWEHH[FOXGHGXQGHUWKH$XVWUDOLDQ
&RQVXPHU/DZ<RXDUHHQWLWOHGWRDUHSODFHPHQWRUUHIXQGIRUDPDMRUIDLOXUHDQG
IRUFRPSHQVDWLRQIRUDQ\RWKHUUHDVRQDEO\IRUHVHHDEOHORVVRUGDPDJH<RXDUHDOVR
HQWLWOHGWRKDYHWKHJRRGVUHSDLUHGRUUHSODFHGLIWKHJRRGVIDLOWREHRIDFFHSWDEOH
quality and the failure does not amount to a major failure.
OPERATING INSTRUCTIONS
11
WARRANTY
$OO7KHUPDQQZDWHUKHDWHUVPXVWEHLQVWDOOHGLQDFFRUGDQFHZLWKPDQXIDFWXUHU¶V
LQVWDOODWLRQLQVWUXFWLRQVDQGLQDFFRUGDQFHZLWKORFDOUHJXODWLRQVEXLOGLQJFRGHV
and AS/NZS3000, AS/NZS3500 and AS/NZS5601.
Where a component may have failed under warranty and is replaced, the component
UHSODFHGZLOORQO\EHFRYHUHGE\WKHZDUUDQW\IRUWKHEDODQFHRIWKHDSSOLDQFH
warranty period.
:DWHU4XDOLW\PXVWEHZLWKLQOLPLWVVSHFL¿HGLQWDEOHEHORZ
pH
6.5 to 8.5
Sodium
Up to 150 mg/litre or ppm
7'67RWDO'LVVROYHG6ROLGV
Up to 600 mg/litre or ppm
Chlorides
Up to 300 mg/litre or ppm
Iron
Up to 1 mg/litre or ppm
Magnesium
Up to 10 mg/litre or ppm
$ONDOLQLW\DV&D&2
Up to 200 mg/litre or ppm
'LVVROYHGIUHH&2
Up to 25 mg/litre or ppm
Total Hardness CaCO3
Up to 200 mg/litre or ppm
Warranty Terms
7KHUPDQQ*DV&RQWLQXRXV)ORZ+RW:DWHU8QLWVDUHFRYHUHGE\5HHFHIRUDQ\FRVW
RIODERXUDQGSDUWVLQWKHHYHQWRIDFRPSRQHQWIDLOXUHGXHWRDQ\GHIHFWVWKDWPD\
arise either from workmanship and/or faulty material.
The Warranty commences on the date of Installation:
Domestic
Heat Exchanger
10 years parts
$OOFRPSRQHQWV
\HDUVSDUWVODERXU
Commercial
$OOFRPSRQHQWV
12
\HDUSDUWVODERXU
OPERATING INSTRUCTIONS
www.thermann.com.au
Works for you.™
0