Download SERVICE MANUAL

HCD-RG333/RG441
SERVICE MANUAL
AEP Model
UK Model
Ver 1.0 2004. 04
HCD-RG333
E Model
HCD-RG441
• HCD-RG333/RG441 is the
tuner, deck, CD and amplifier
section in MHC-RG333/RG441.
(Photo: HCD-RG333)
CD
Section
Model Name Using Similar Mechanism
NEW
CD Mechanism Type
CDM74-F1BD81
Optical Pick-up Name
KSM-215DCP/C2NP
Tape Deck Model Name Using Similar Machanism
NEW
Section
CWM43FF-25
Tape Transport Mechanism Type
SPECIFICATIONS
Amplifier section
European and Russian models:
HCD-RG333:
DIN power output (rated): 100 + 100 watts
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference):
125 + 125 watts (6 ohms at
1 kHz, 10% THD)
Music power output (reference):
250 + 250 watts (6 ohms at
1 kHz, 10% THD)
Other models:
HCD-RG441:
The following measured at AC 120, 127, 220, 240 V,
50/60 Hz
DIN power output (rated): 120 + 120 watts
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference):
150 + 150 watts (6 ohms at
1 kHz, 10% THD)
Inputs
GAME INPUT AUDIO L/R (phono jacks):
voltage 250 mV,
impedance 47 kilohms
GAME INPUT VIDEO (phono jack):
1 Vp-p, 75 ohms
Outputs
PHONES (stereo mini jack):
accepts headphones of
8 ohms or more
VIDEO OUT (phono jack): max. output level
1 Vp-p, unbalanced, Sync
negative, load impedance
75 ohms
SPEAKER:
accepts impedance of 6 to
16 ohms
– Continued on next page –
MINI HI-FI COMPONENT SYSTEM
9-877-772-01
Sony Corporation
2004D04-1
© 2004. 04
Home Audio Company
Published by Sony Engineering Corporation
1
HCD-RG333/RG441
CD player section
System
Laser
Frequency response
Signal-to-noise ratio
Dynamic range
General
Compact disc and digital
audio system
Semiconductor laser
(λ=770 – 810 nm)
Emission duration:
continuous
2 Hz – 20 kHz (±0.5 dB)
More than 90 dB
More than 90 dB
Tape deck section
Recording system
Frequency response
4-track 2-channel, stereo
50 – 13,000 Hz (±3 dB),
using Sony TYPE I
cassettes
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
Antenna
Antenna terminals
Intermediate frequency
87.5 – 108.0 MHz (50 kHz step)
FM lead antenna
75 ohms unbalanced
10.7 MHz
AM tuner section
Tuning range
European models:
Other models:
Antenna
Antenna terminals
Intermediate frequency
2
531 – 1,602 kHz (with the tuning
interval set at 9 kHz)
530 – 1,710 kHz (with the tuning
interval set at 10 kHz)
531 – 1,602 kHz (with the tuning
interval set at 9 kHz)
AM loop antenna
External antenna terminal
450 kHz
Power requirements
European models:
Argentine model:
Mexican model:
Other models:
Power consumption
European models:
HCD-RG333:
Other models:
HCD-RG441:
230 V AC, 50/60 Hz
220 V AC, 50/60 Hz
127 V AC, 60 Hz
120 V, 220 V or 230 –
240 V AC, 50/60 Hz
Adjustable with voltage
selector
180 watts
0.25 watts
(at the Power Saving Mode)
155 watts
Dimensions (w/h/d) incl. projecting parts and controls
Amplifier/Tuner/Tape/CD section:
Approx. 280 × 327 × 425 mm
Mass
European models:
HCD-RG333:
Other models:
HCD-RG441:
Approx. 10.0 kg
Approx. 10.0 kg
Design and specifications are subject to change without
notice.
HCD-RG333/RG441
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale. The
Simpson 250 and Sanwa SH-63Trd are examples of a passive
VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are suitable. (See Fig. A)
To Exposed Metal
Parts on Set
0.15 µF
1.5 kΩ
AC
Voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
3
HCD-RG333/RG441
The release method of a CD disc tray LOCK function
There is a disc lock function for the disc theft prevention for a
demonstration at a shop front in this machine.
Procedue:
1. Press the ?/1 button to turn the set on.
2. Press two buttons of x and Z (EJECT) simultaneously for
five seconds.
3. The message “LOCKED” is displayed and the tray is locked.
(Even if exiting from this mode, the tray is still locked.)
4. Press two buttons of x and Z (EJECT) simultaneously for
five seconds again.
5. The message “UNLOCKED” is displayed and the tray is
unlocked.
6. To exit from this mode, press the ?/1 button to turn the set
off.
Unleaded solder
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow) than
ordinary solder so use caution not to let solder bridges occur such
as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
Laser component in this product is capable
of emitting radiation exceeding the limit for
Class 1.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of soldering iron around 270°C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
4
HCD-RG333/RG441
TABLE OF CONTENTS
1. SERVICING NOTE
1-1. Service Position-1 (AMP Board) ........................................ 6
1-2. Service Position-2 (BD81A Board) .................................... 6
2. GENERAL
Main Unit ................................................................................ 7
Remote Control ....................................................................... 8
3. DISASSEMBLY
3-1. Case (Top) ......................................................................... 10
3-2. CD Door ............................................................................ 10
3-3. Front Panel Section ........................................................... 11
3-4. CD Mechanism Deck ........................................................ 11
3-5. Tape Mechanism Deck, Game Jack Board ........................ 12
3-6. Panel Board ....................................................................... 12
3-7. Back Panel Section, Sub Trans Board ............................... 13
3-8. Trans Board ....................................................................... 13
3-9. Main Board ....................................................................... 14
3-10. Amp Board ........................................................................ 14
3-11. BD81A Board ................................................................... 15
3-12. Connect Board ................................................................... 15
3-13. Driver Board, SW Board ................................................... 16
3-14. Optical Pick-up ................................................................. 16
3-15. Sensor Board ..................................................................... 17
3-16. Motor (TB) Board ............................................................. 17
3-17. Motor (LD) Board ............................................................. 18
4. TEST MODE ..................................................................... 19
5. DIAGRAMS
5-1.
5-2.
5-3.
5-4.
IC Pin Descriptions ........................................................... 22
Block Diagram –CD Section– ........................................... 27
Block Diagram –Main Section– ........................................ 28
Block Diagram –Panel/Power Section– ............................ 29
5-5. Circuit Boards Location .................................................... 30
5-6. Note for Printed Wiring Boards
and Schematic Diagrams .................................................. 31
5-7. Waveforms ......................................................................... 31
5-8. Printed Wiring Board –CD Mechanism Section (1/2)– .... 32
5-9. Schematic Diagram –CD Mechanism Section (1/2)– ....... 33
5-10. Printed Wiring Boards –CD Mechanism Section (2/2)– ... 34
5-11. Schematic Diagram –CD Mechanism Section (2/2)– ....... 35
5-12. Schematic Diagram –Main Section (1/2)– ........................ 36
5-13. Schematic Diagram –Main Section (2/2)– ........................ 37
5-14. Printed Wiring Board –Main Section– .............................. 38
5-15. Printed Wiring Boards –Panel Section– ............................ 39
5-16. Schematic Diagram –Panel Section (1/2)– ....................... 40
5-17. Schematic Diagram –Panel Section (2/2)– ....................... 41
5-18. Printed Wiring Boards –Jack Section– .............................. 42
5-19. Schematic Diagram –Jack Section– .................................. 43
5-20. Printed Wiring Board –Power Amp Section (RG333)– .... 44
5-21. Printed Wiring Boards –Transformer Section (RG333)– .. 45
5-22. Schematic Diagram –Power Section (RG333)– ................ 46
5-23. Printed Wiring Board –Power Amp Section (RG441)– .... 47
5-24. Printed Wiring Boards –Transformer Section (RG441)– .. 48
5-25. Schematic Diagram –Power Section (RG441)– ................ 49
5-26. IC Block Diagrams ............................................................ 50
6. EXPLODED VIEWS
6-1.
6-2.
6-3.
6-4.
6-5.
6-6.
6-7.
Main Section ..................................................................... 52
Front Panel Section (1) ...................................................... 53
Front Panel Section (2) ...................................................... 54
Front Panel Section (3) ...................................................... 55
Main Board Section .......................................................... 56
CD Mechanism Section (1) ............................................... 57
CD Mechanism Section (2) ............................................... 58
7. ELECTRICAL PARTS LIST ........................................ 59
5
HCD-RG333/RG441
SECTION 1
SERVICING NOTE
1-1. SERVICE POSITION-1 (AMP BOARD)
To inspect the AMP board, turn both of the front panel
and the CD mechanism deck so that the left side of the product faces down.
CD mechanism deck
front panel
AMP board
1-2. SERVICE POSITION-2 (BD81A BOARD)
Remove the CD mechanism deck and place it on top of the pedestal as shown.
Inspect the BD81A bard in this set up.
BD81A board
CD mechanism deck
6
HCD-RG333/RG441
SECTION 2
GENERAL
This section is extracted
from instruction manual.
7
HCD-RG333/RG441
8
HCD-RG333/RG441
SECTION 3
DISASSEMBLY
Note : Disassemble the unit in the order as shown below.
SET
3-1.
CASE (TOP)
(Page 10)
3-2.
CD DOOR
(Page 10)
3-3.
FRONT PANEL SECTION
(Page 11)
3-4.
CD MECHANISM DECK
(Page 11)
3-5.
TAPE MECHANISM DECK,
GAME JACK BOARD
(Page 12)
3-6.
PANEL BOARD
(Page 12)
3-11. BD81A BOARD
(Page 15)
3-12. CONNECT BOARD
(Page 15)
3-15. SENSOR BOARD
(Page 17)
3-14. OPTICAL PICK-UP
(Page 16)
3-13. DRIVER BOARD,
SW BOARD
(Page 16)
3-16. MOTOR (TB) BOARD
(Page 17)
3-7.
BACK PANEL SECTION,
SUB TRANS BOARD
(Page 13)
3-8.
TRANS BOARD
(Page 13)
3-17. MOTOR (LD) BOARD
(Page 18)
3-9.
MAIN BOARD
(Page 14)
3-10. AMP BOARD
(Page 14)
9
HCD-RG333/RG441
Note : Follow the disassembly procedure in the numerical order given.
3-1. CASE (TOP)
qf
qd two screws
(+BVTP 3 × 10)
qh case (top)
7 two screws
(case 3 TP2)
qs case (side-L)
qg
9 screw
(+BVTP 3 × 10)
qf
qa
6 case (side-R)
5
0 screw
(+BVTP 3 × 10)
3 screw
(+BVTP 3 × 10)
8 screw
(case 3 TP2)
1 two screws
(case 3 TP2)
4 screw
(+BVTP 3 × 10)
2 screw
(case 3 TP2)
3-2. CD DOOR
3 two claws
4 CD door
CD mechanism deck (CDM74)
1 Turn the pulley to the direction of the arrow.
Front panel side
pulley
2 Pull-out the disc tray.
10
HCD-RG333/RG441
3-3. FRONT PANEL SECTION
4 screw
(+BVTP 3 × 8)
qa CN304
1 CN805
3 CN873
8 screw
(+BVTP 3 × 10)
5 screw (+BVTP 3 × 8)
qs CN112
7 screw (+BVTP 3 × 10)
0 CN309
qd CN103
9
2 CN302
qf front panel section
6 three screws
(+BVTP 3 × 8)
3-4. CD MECHANISM DECK
1 three screws
(+BVTP 3 × 10)
4 CD mechanism deck
MAIN board
2 CN701
3 CN874
MAIN board
11
HCD-RG333/RG441
3-5. TAPE MECHANISM DECK, GAME JACK BOARD
4 LEAD board
3 tape mechanism deck
2 six screws
(+BVTP 2.6 × 8)
1 connector
6 GAME JACK board
5 two screws
(+BVTP 2.6 × 8)
3-6. PANEL BOARD
4 seven claws
2 eight screws
(+BVTP 2.6 × 8)
6 CN604
5 CN605
3 two screws
(+BVTP 2.6 × 8)
7 PANEL board
1 connector
12
HCD-RG333/RG441
3-7. BACK PANEL SECTION, SUB TRANS BOARD
0 SUB TRANS board
qa back panel section
3 CN901
9 two screws
(+BVTP 3 × 10)
2 CN906
7 two screws
(+BVTP 3 × 10)
1 CN904
8
6 two screws
(+BVTP 3 × 10)
5 CN308
4 CN101
3-8. TRANS BOARD
5 four screws
(+ITC 4 × 8)
6 TRANS board
3 screw
(+BVIT 3 × 8R)
1 CN905
2 CN907
4 earth wire
13
HCD-RG333/RG441
3-9. MAIN BOARD
4 MAIN board
1 CN907
MAIN board
3 CN441
2 two screws
(+BVTP 3 × 8)
3-10. AMP BOARD
4 two screws
(+BVIT 3 × 8R)
2 two screws
(+BVTT 4 × 8)
3 screw
(+BVTP 3 × 14)
7 heat sink
5 two screws
(transistor)
6
8 AMP board
1 CN905
14
HCD-RG333/RG441
3-11. BD81A BOARD
3 screw
(+BVTP 2.6 × 8)
1 CN202
4 gap tube
6 BD81A board
5 Remove soldering from the four points.
2 CN101
3-12. CONNECT BOARD
2 two screws
(+BVTP 2.6 × 8)
1 CN871
3 CONNECT board
15
HCD-RG333/RG441
3-13. DRIVER BOARD, SW BOARD
1 two screws
(+BTTP (M2.6))
3 CN703
4 DRIVER board
5 screw
(+BTTP (M2.6))
6 SW board
2 CN702
3-14. OPTICAL PICK-UP
1 floating screw
(+PTPWH M2.6)
2 holder (213) ASSY
qd optical pick-up
(KSM-215DCP/C2NP)
qs
7 two insulators
6 two coil springs
(insulator)
qa two insulators
0 two coil springs
(insulator)
9 two stoppers (BU)
8 two screws
(BVTT M2.6)
16
5 stopper (BU)
4 screw
(BVTT M2.6)
3 floating screw
(+PTPWH M2.6)
HCD-RG333/RG441
3-15. SENSOR BOARD
1 floating screw
(+PTPWH M2.6)
2 tray
8 screw
(+BTTP (M2.6))
3 belt (table)
0 SENSOR board
4 floating screw
(+PTPWH M2.6)
5 pulley (table)
9 CN731
6 floating screw
(+PTPWH M2.6)
7 gear (geneva)
3-16. MOTOR (TB) BOARD
2 stopper
4
1 stopper
7 table motor assy (M741)
3 CN742
8 MOTOR (TB) board
6 Remove the two solderings of motor.
5 two screws
(+BTTP (M2.6))
17
HCD-RG333/RG441
3-17. MOTOR (LD) BOARD
2 two screws
(+BTTP (M2.6))
4 Remove the two solderings of motor.
3 MOTOR (LD) board
5 loading motor assy (M751)
1 belt (loading)
18
HCD-RG333/RG441
SECTION 4
TEST MODE
[Change-over of AM Tuner Step between 9 kHz and
10 kHz]
• A step of AM channels can be changed over between 9 kHz and
10 kHz.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “TUNER”, and press TUNER/BAND
button to select the BAND “AM”.
3. Press ?/1 button to turn the set OFF.
4. Press TUNER/BAND and ?/1 buttons simultaneously, and
the display of fluorescent indicator tube changes to “AM 9 k
STEP” or “AM 10 k STEP”, and thus the channel step is changed
over.
[Cold Reset]
• The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. Press three buttons x , PLAY MODE/TUNING MODE ,
and DISC 1 simultaneously.
2. The fluorescent indicator tube displays “COLD RESET” and
the set is reset.
[Aging Mode]
This mode can be used for operation check of CD section and tape
deck section.
• If an error occurred:
The aging operation stops and is displayed status.
• If no error occurs:
The aging operation continues repeatedly.
1. Operating method of Aging Mode
Turn on the main power and select “CD” of the function.
1) Set three discs in tray. Select ALL DISCS, and REPEAT OFF.
2) Load the tapes recording use into both decks.
3) Press three buttons x , PLAY MODE/TUNING MODE ,
and EX-CHANGE simultaneously.
4) Aging operations of CD and tape are started at the same time.
5) To exit the aging mode, perform [Cold Reset].
2. Aging mode in CD section
1) Operation during aging mode
• In the agining mode, the program is excuted in the following
sequence.
(1) The disc tray opens and closes.
(2) The disc tray turns to select a disc 3.
(3) The pick-up accesses to the first track, and plays 3 seconds.
(4) The pick-up accesses to the last track, and plays 3 seconds.
(5) The disc tray opens and closes.
(6) The disc tray turns to select a disc 1.
(7) The same operation starts like step (3).
(8) After a disc 1 aging operation, a disc 2 is selected.
(9) When an aging operation of a disc 3 is completed, the display
“AGING ∗∗∗∗” value increases.
(10) If no error occurs, the aging operation continues repeatedly.
2) Error display
Disc error
Display
E00D01022
Error
Focus error (No disc)
E00D02022
Sub Q error (Focus is good)
E00D02023
TOC reading error
E00D02014
Access error (Unable within regular time)
Mechanism error
Display
E00M__E_0
Error
Error during opening tray
E00M__C_2
EX-CHANGE disc error
E00M__D_0
Error during closing tray
E00M__F_3
EX-OPEN error
E00M__D_5
EX-CLOSE error
E00M__C_2
Chuck-up error
E00M__C_3
Unchucking error
3. Aging mode in Tape Deck section
1) Operation during aging mode
• In the agining mode, the program is excuted in the following
sequence.
Step
Operation
Display
1
Rewind the TAPE A
TAPE
AAG-1
2
Rewind the TAPE B
TAPE
BAG-2
3
Play the TAPE A (1 minute)
TAPE
AAG-2
4
Stop the TAPE A (1 second)
TAPE
AAG-3
5
Play the TAPE A (3 minutes)
TAPE
AAG-4
6
Rewind(AMS) the TAPE A
TAPE
AAG-5
7
F.F.(AMS) the TAPE A
TAPE
AAG-6
8
Play the TAPE B (1 minute)
TAPE
BAG-2
9
Stop the TAPE B (1 second)
TAPE
BAG-3
10
Record the TAPE B (3 minutes)
TAPE
BAG-4
11
Rewind(AMS) the TAPE B
TAPE
BAG-5
12
F.F.(AMS) the TAPE B
TAPE
BAG-6
2) Error display
• If error occurred, the display remains like “TAPE BAG-2”.
4. Exiting from the aging mode
• Be sure to perform Cold Reset to exit from the aging mode.
19
HCD-RG333/RG441
[PANEL Test Mode]
• All fluorecent segments and LEDs are tested.
• Keyboard check.
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and ENTER simultaneously.
3. All segments and LEDs (without STANDBY LED) are turned
on.
4. Press X and ENTER buttons simultaneously, and the key
check mode is activated.
5. The message “KEY 0 0 0 ” is displayed.
Each time a button is pressed, the key code number is displayed.
6. Press X and ENTER buttons simultaneously, and the key
count mode is activated.
7. The message “KEYCNT 0” is displayed.
Each time a button is pressed, “KEYCNT 0” value increased.
However, once a button is pressed, it is no longer taken into
account.
8. Press X and ENTER buttons simultaneously, and the head
phone detect mode is activated.
9. The message “H_P OFF” is displayed when a headphone jack
is not inserted.
“H_P ON ” is displayed when a headphone jack is inserted.
10. Press X and ENTER buttons simultaneously, and the volume
control detect mode is activated.
11. The message “VOLUME FLAT” is displayed.
“VOLUME UP” is displayed if rotating MASTER VOLUME
knob clockwise, or “VOLUME DOWN” is displayed if rotating
counterclockwise.
12. To exit from the GC test mode after the head phone detect mode,
press X and ENTER buttons simultaneously.
[Version and Destination Display Mode]
• The version or destination is displayed.
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and DISC 2 simultaneously.
3. The destination is displayed.
4. Press DISPLAY buttons simultaneously.
5. The version is displayed.
6. To exit from this mode, press ?/1 button to turn the set OFF.
[CD Service Mode]
• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pick-up.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. To enter the test mode, press three buttons x , PLAY MODE/
TUNING MODE , and Z simultaneously.
4. The CD service mode is selected.
5. With the CD in stop status, press M button to move the
pick-up to outside track, or press m button to inside track.
6. To exit from this mode, perform as follows:
1) Move the pick-up to the most inside track.
2) Press ?/1 button to turn the set OFF.
Note: • Always move the pick-up to most inside track when exiting from
this mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can be
chipped.
20
[MC Test Mode]
• This mode is used to test the function of the equalizer.
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and DISC 3 simultaneously.
3. Press the EQ + button.
The function of the equalizer is set to “MIN”.
4. Press the EQ – button.
The function of the equalizer is set to “MAX”.
5. Press the PRESET EQ button.
The function of the equalizer is set to “EQ FLAT”.
6. MASTER VOLUME up and down.
“VOLUME MIN” “VOLUME 16” “VOLUME MAX” is
displayed.
7. Press the GROOVE button.
The message “VACS OFF” or “VACS ON” is displayed.
8. To exit from this mode, press ?/1 button to turn the set OFF.
[CD Ship Mode (LOCK) ]
• This mode moves the pick-up to the position durable to vibration. Use this mode when returning the set to the customer after
repair.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. Press ?/1 button to turn the set OFF.
4. Press CD button and ?/1 button simultaneously.
5. The “STANDBY” display blinks instantaneously, and the CD
ship mode is set.
[CD Ship (LOCK) & COLD RESET MODE]
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. Press ?/1 button to turn the set OFF.
4. Press three buttons x , CD and DISPLAY simultaneously.
5. The “STANDBY” display blinks instantaneously and CD ship
mode is set.
6. To fluorescent indicator tube displays “COLD RESET” and
the set is reset.
[Disc Tray Lock]
Procedure:
1. Press the ?/1 button to turn the set ON.
2. Press two buttons of x and Z simultaneously for five seconds.
3. The message “LOCKED” is displayed and the tray is locked.
(Even if exiting from this mode, the tray is still locked.)
4. Press two buttons of x and Z simultaneously for five seconds
again.
5. The message “UNLOCKED” is displayed and the tray is
unlocked.
6. To exit from this mode, press the ?/1 button to turn the set
OFF.
HCD-RG333/RG441
[CD Repeat 5 Times Limit Release Mode]
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. Press three buttons x , CD and ENTER simultaneously.
4. The message “LIMIT OFF” is displayed.
5. Press ?/1 button the set OFF.
[AMP TEST MODE]
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press three buttons x , PLAY
MODE/TUNING MODE and ENTER simultaneously.
3. Press the DISPLAY button.
The message “V0 0 0” “ 000” is displayed.
4. Press the GROOVE button.
The message “DBFB ON” “DBFB OFF” is displayed.
5. Press the SURROUND button.
The message “SURROUND ON” “SURROUND OFF” is
displayed.
6. Press the EQ BAND button.
The message “LOW” “MID” “HIGH” is displayed.
7. Press ?/1 button to turn the set OFF.
21
HCD-RG333/RG441
SECTION 5
DIAGRAMS
5-1. IC PIN DESCRIPTIONS
• IC101 CXD3059AR (RF AMP) (BD81A BOARD)
Pin No.
Pin Name
I/O
1
MIRR
I/O
Mirror signal input/output
22
Pin Description
Not used in this set. (Open)
2
3
DFCT
FOK
I/O
I/O
Defect signal input/output Not used in this set. (Open)
Focus OK signal input/output Not used in this set. (Open)
4
VSS
—
5
LOCK
I/O
Internal digital ground pin
GFS is sampled at 460Hz; when GFS is high , this pin outputs a high signal
6
MDP
O
If GFS is low eight consecutive Not used in this set. (Open)
Spindle motor servo control signal output
7
8
SSTP
IOVSS1
I
—
Disc innermost detection signal input
I/O digital ground pin
9
10
SFDR
SRDR
O
O
Sled drive signal output
Sled drive signal output
11
12
TFDR
TRDR
O
O
Tracking drive signal output
Tracking drive signal output
13
14
FFDR
FRDR
O
O
Focus drive signal output
Focus drive signal output
15
16
IOVDD1
AVDD0
—
—
I/O digital power supply pin (+3.3 V)
Analog power supply pin (+3.3 V)
17
18
AVSS0
NC
—
—
Analog ground pin
Not used. (Open)
19
20
E
F
I
I
E signal input
F signal input
21
22
23
TEI
TEO
FEI
I
O
I
Tracking error signal input
Tracking error signal output
Focus error signal input
24
25
FEO
VC
O
O
Focus error signal output
Center voltage output
26
27
A
B
I
I
A signal input
B signal input
28
29
C
D
I
I
C signal input
D signal input
30
31
NC
AVDD4
—
—
Not used. (Open)
Analog power supply pin (+3.3 V)
32
33
RFDCO
PDSENS
O
I
RFDC signal output Not used in this set. (Open)
Reference voltage pin for PD Connect to ground in this set.
34
35
AC_SUM
EQ_IN
O
I
RFAC summing amplifier signal output
Equalizer circuit signal input
36
37
LD
PD
O
I
APC amplifier signal output
APC amplifier signal input
38
39
NC
RFC
—
I
Not used. (Open)
Equalizer cut-off frequency adjustment pin
40
41
AVSS4
RFACO
—
O
Analog ground pin
RFAC signal output
42
43
RFACI
AVDD3
I
—
RFAC signal input or EFM signal input
Analog power supply pin (+3.3 V)
44
45
BIAS
ASYI
I
I
Asymmetry circuit constant current signal input
Asymmetry comparator voltage signal input
46
47
ASYO
VPCO
O
O
EFM full-swing signal output (Low=VSS, High=VDD)
Wide-band EFM PLL charge pump signal output Not used in this set. (Open)
48
49
VCTL
AVSS3
I
—
Wide-band EFM PLL VCO2 control voltage signal input
Analog ground pin
50
CLTV
I
Multiplier VCO1 control voltage signal input
HCD-RG333/RG441
Pin No.
51
Pin Name
FILO
I/O
O
Pin Description
Master PLL (slave=digital PLL) filter signal output
52
53
FILI
PCO
I
O
Master PLL filter signal input
Master PLL charge pump signal output
54
55
AVDD5
DDVROUT
—
O
Analog power supply pin (+3.3 V)
DC/DC converter signal output
56
57
DDVRSEN
AVSS5
I
—
DC/DC converter output voltage monitor pin
Analog ground pin
58
59
DDCR
NC
I
—
DC/DC converter reset pin
Not used. (Open)
60
61
BCKI
PCMDI
I
I
D/A interface bit clock signal input
D/A interface serial data signal input (2’s COMP, MSB first)
62
63
LRCKI
LRCK
I
O
D/A interface LR clock signal input
D/A interface LR clock signal output f=Fs
64
65
VSS
PCMD
—
O
Internal digital ground pin
D/A interface serial data signal output (2’s COMP, MSB first)
66
67
BCK
VDD
O
—
D/A interface bit clock signal output
Internal digital power supply pin (+3.3 V)
68
69
EMPH
EMPHI
O
I
High when the playback disc has emphasis, low it has not
High when de-emphasis is ON, low when input OFF
70
71
IOVDD2
DOUT
—
O
I/O digital power supply pin (+3.3 V)
Digital signal output
72
73
TEST
TES1
I
I
74
75
76
IOVSS2
NC
XVSS
—
—
—
I/O digital ground pin
Not used. (Open)
Master clock ground pin
77
78
XTAO
XTAI
O
I
Crystal oscillation circuit signal output (16.9 MHz)
Crystal oscillation circuit signal input (16.9 MHz)
79
80
XVDD
AVDD1
—
—
Master clock power supply pin (+3.3 V)
Analog power supply pin (+3.3 V)
81
82
AOUT1
VREFL
O
O
Lch analog signal output
Lch reference voltage signal output
83
84
AVSS1
AVSS2
—
—
Analog ground pin
Analog ground pin
85
86
VREFR
AOUT2
O
O
Rch reference voltage signal output
Rch analog signal output
87
88
AVDD2
NC
—
—
Analog power supply pin (+3.3 V)
Not used. (Open)
89
90
IOVDD0
RMUT
—
O
I/O digital power supply pin (+3.3 V)
Rch “0” detection flag Not used in this set. (Open)
91
92
LMUT
NC
O
—
Lch “0” detection flag
Not used. (Open)
Not used in this set. (Open)
93
94
XTSL
IOVSS0
I
—
Crystal selection input
I/O digital ground pin
Not used in this set. (Connect to ground.)
95
XTACN
I
Oscillation circuit control signal input
Self-oscillation when high, oscillation stop when low
96
SQSO
O
Subcode Q 80-bit and PCM peak and level data signal output
CD TEXT data signal output Not used in this set. (Open)
97
98
SQCK
SBSO
I
O
SQSO readout clock signal input
Subcode P to W serial signal output Not used in this set. (Open)
99
100
EXCK
XRST
I
I
SBSO readout clock signal input Not used in this set. (Open)
System reset signal input “L”: Reset
101
SYSM
I
Mute signal input “H”: Mute Connect to ground in this set.
Test pin Normally ground
Test pin Normally ground
23
HCD-RG333/RG441
Pin No.
102
Pin Name
DATA
I/O
I
Serial data signal input
103
104
VSS
XLAT
—
I
Internal digital ground pin
Latch signal input The serial data is latched at the falling edge
105
106
CLOCK
VDD
I
—
Serial data transfer clock signal input
Internal digital power supply pin (+3.3 V)
107
108
SENS
SCLK
O
I
SENS signal output
SENS serial data readout clock signal input
109
110
ATSK
WFCK
I/O
O
111
112
XUGF
XPCK
O
O
XUGF signal output Not used in this set. (Open)
XPCK signal output Not used in this set. (Open)
113
114
GFS
C2PO
O
O
GFS signal output Not used in this set. (Open)
C2PO signal output Not used in this set. (Open)
115
116
SCOR
VDD
O
—
High output when the subcode sync, S0 or S1, is detected
Internal digital power supply pin (+3.3 V)
117
118
C4M
WDCK
O
O
4.2336MHz signal output Not used in this set. (Open)
Word clock signal output f=2Fs Not used in this set. (Open)
119
120
COUT
NC
I/O
—
24
Pin Description
Anti-shock signal input/output Not used in this set. (Open)
WFCK signal output Not used in this set. (Open)
Track number count signal input/output Not used in this set. (Open)
Not used. (Open)
HCD-RG333/RG441
• IC601 LC876996A-53H2-E (SYSTEM CONTROLLER) (PANEL BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
O-MP3 CS
O
CS signal output to CD digital processor
2
3
O-MP3 LP MOTER
I-MP3 ACK SOL-B
O
I
LP signal output to CD digital processor and motor signal output
ACK signal input from CD digital processor and motor signal input
4
5
O-MP3 REQ SOL-A
I-SCOR
O
I
REQ signal output to CD digital processor and motor signal output
CD scor signal input
6
7
O-MP3 RESET
I-BU1924 DATA
O
I
RESET signal output to CD digital processor
RG333: RDS data signal input RG441: Not used in this set. (Connect to ground.)
8
9
I-BU1924 CLK
I-VOLUME-IN1
I
I
RG333: RDS clock signal input RG441: Not used in this set. (Connect to ground.)
Volume signal input from the encoder
10
11
I-VOLUME-IN2
RESET
I
I
Volume signal input from the encoder
Reset signal input
12
13
I-XT1
I-XT2
I
O
Connection for input a crystal resonator (32.768 kHz)
Connection for input a crystal resonator (32.768 kHz)
14
15
VSS1
CF1
—
I
Ground pin
Connection for input a ceramic resonator (10 MHz)
16
17
CF2
VDD1
O
—
Connection for input a ceramic resonator (10 MHz)
Power supply pin (+1.5 V)
18
19
I-PROTECT
WFR/HP/MIC-IN
I
I
Power amplifier circuit protection signal input
SubWoofer or Headphone detection signal input
20
21
I-CD ENCODER
I-CD OPEN/CLOSE
I
I
Signal input from the CD encoder
CD tray open switch signal input
22
23
I-TAPE A START
I-TAPE B START
I
I
TAPE A switches signal input
TAPE B switches signal input
24
25
26
I-STREAM/VACS
I-KEY 3
I-KEY 2
I
I
I
Stream/Vacs signal input
Function key input 3
Function key input 2
27
28
I-KEY 1
I-SIRDS-IN
I
I
Function key input 1
Data signal input from the remote contorol receiver
29
30 to 42
I-AC CUT
G13 to G1
I
O
Power down signal input
FL tube grid signal output
43 to 45
46
S1 to S3
VDD3
O
—
FL tube segment signal output
Power supply pin (+3.3 V)
47 to 49
50
S4 to S6
S7/METER-SW1
O
O
FL tube segment signal output
FL tube segment signal output
51
52
–VPP
S8/METER-SW2
—
O
Power supply (–) pin (–26 V)
FL tube segment signal output
53
54 to 63
S9/METER-SW3
S10/SW1 to S19/SW10
O
O
FL tube segment signal output
FL tube segment signal output
64, 65
66
S20, S21
I-SPEC/MODEL/METER
O
I
FL tube segment signal output
METER swich signal input
67
68
I-TUNED-IN
I-STEREO-IN
I
I
Tuning frequency signal input
Stereo tuning signal input
69
70
I-AMS-IN
I-REEL-A-IN
I
I
AMS signal input
A deck photo sensor signal input
71
72
I-REEL-B-IN
VDD4
I
—
B deck photo sensor signal input
Power supply pin (+3.3 V)
73
74
I-CD NUM SENSOR
O-POWER-RELAY
I
O
Table address sensor swich signal input
POWER RELAY control signal output
75
76
O-SYSTEM-MUTE
O-POWER-LED
O
O
System muting signal output
POWER LED control signal output
77
78
STREAM-LED6/SOL B
STREAM-LED5/SOL A
O
O
Illumination LED control signal output
Illumination LED control signal output
25
HCD-RG333/RG441
Pin No.
79
Pin Name
STREAM-LED4/MOTOR
I/O
O
80
81
STREAM-LED3/MP3-STB
STREAM-LED2
O
O
Illumination LED control signal output
Illumination LED control signal output
82
83
STREAM-LED1
I-LC72121 DI
O
I
Illumination LED control signal output
Data signal input from tuner
84
85
O-LC72121 CE
O-LC72121/BU2099FV DO
O
O
Chip select signal output to tuner
Data signal input from tuner and SP driver
86
87
O-LC72121/BU2099FV CLK
O-BU2099FV LCH
O
O
Clock signal output to tuner and SP driver
LCH signal output to SP driver
88
89
O-BD3401 CLK
VSS2
O
—
Clock signal output to sound processor
Ground pin
90
91
VDD2
O-BD3401 DATA
—
O
Power supply pin (+3.5 V)
Data signal output to sound processor
92
93
O-XTCN
O-XRES (RESET)
O
O
CD XTCN signal output
CD reset signal output
94
95
O-XLT (CD-LAT)
O-CD-DATA
O
O
CD latch signal output
CD data signal output
96
97
I-SENS
O-CD-CLK
I
O
CD SENS signal input
CD clock signal output
98
99
O-MP3-DO
I-MP3-DI
O
I
MP3 data signal output to CD digital processor
MP3 data signal input from CD digital processor
100
O-MP3-CLK
O
MP3 clock signal output to CD digital processor
26
Pin Description
Illumination LED control signal output
HCD-RG333/RG441
5-2. BLOCK DIAGRAM — CD SECTION —
OPTICAL PICK-UP
BLOCK
(KSM-215DCP)
DETECTOR
VC
DIGITAL
SIGNAL PROCESSOR
IC301
RF AMP
IC101
+1.7V
+3.3V
VCC
A
26 A
PCMDI 61
11 SDO0
B
27 B
LRCKI 62
16 LRCKIA
VDD 55
C
28 C
LRCK 63
19 SFSY/LRCKIB
D
29 D
PCMD 65
14 SDIO
E
19 E
BCK 66
15 BCKIA
F
20 F
BCKI 60
18 SBSY/BCKIB
LD
LD
DRIVER
Q10
+3.3V
VR
SL/SP MOTOR
DRIVER
IC251
F+
FOCUS
COIL
F
T+
TRACKING
COIL
T
S101
(LIMIT)
XLAT 104
CLOCK 105
SENS 107
SCOR 115
MP3-REQ
MP3-ACK
MP3-CLK
MIDIO 6
MP3-DI
MILP 5
MP3-LP
MICS 4
MP3-CS
XRST
RESET 2
MP3-RST
CH1FIN 5
XLT
SCOR
CLOCK
SENS
SENS
CLOCK
SCOR
XLT
XTCN
13 FFDR
DOUT
18 CH1OUT-F
MP-3STB
OPIN+ 3
B
MAIN
SECTION
(Page 28)
14 FRDR
9 SFDR
AOUT1 81
10 SRDR
AOUT2 86
6 MPD
DOUT 71
• R-CH is omitted due to same as L-CH.
• Signal Path
21 CH3OUT-F
M
RE701
XRST
CD-R
CH3RIN 29
M102
(SLED)
CD-DATA
CD-L
20 CH4OUT-F
: CD
22 CH3OUT-R
MUTE 24
27
OUT1 4
OUT2 2
M
M751
(LOADING)
M
M741
(TABLE)
TBL MOTOR DRIVER
IC712
9 RIN
7 FIN
OUT1 4
OUT2 2
D+3.3V
XLT(CD-LAT)
12 TRDR
19 CH4OUT-R
9 RIN
7 FIN
CD-CLOCK
17 CH1OUT-R
CH3FIN 30
S751
(OPEN)
SENS
XRST
11 TFDR
PANEL
SECTION
(Page 29)
XTACN
CH2FIN 7
A
D
LM-R
LM-F
TM-R
TM-F
TBL ADDRESS SENS
E-1
E-2
E-3
OPEN SW
SCOR
DATA
15 CH2OUT-R
CH1RIN 6
MAIN
SECTION
(Page 28)
DATA
16 CH2OUT-F
CH2RIN 8
M101
M
(SPINDLE)
XRST 100
DATA 102
7 SSTP
MP3-DO
XTACN
78 XTAI
37 PD
LD MOTOR DRIVER
IC701
MIACK 8
MICK 7
XTACN 95
PD
+3.3V
VDD 21
VDDM 40
PO11/BUCK/AD1 36
77 XTAO
X171
16.9344MHz
+1.5V REG
1
IC303
STANBY 3
36 LD
GND
5
27
E-3
E-2
E-1
ROTARY
ENCODER
TBL ADDRESS
SENSE SWITCH
Q731
TABLE SENSOR
IC731
HCD-RG333/RG441
5-3. BLOCK DIAGRAM — MAIN SECTION —
SOUND PROCESSOR
IC101
CD
SECTION
MP3-STB
CD-L
CD-R
B
(Page 27)
1 CDL
R-CH
VOUT1 33
VOUT2 32
MUTE
Q306
MUTE
CONTROL
Q304,305
BUFFER
IC102
RG333
RG441
POWER AMP
IC441
R-CH
DO
DI
CLK
CE
TUNED
STEREO
RG333
RDS DATA
RDS INT
RG441:Q489-491
RG333:Q489
OVERLOAD DET
Q441,442
RELAY DRIVE
Q485-488
61 TUNER_L
DO
DI
CLK
CE
TUNED
STEREO
Q483,Q484
TH441
BBIN1 35
DATA
RDS DATA
RDS CLK
RCLK
19 SI
BBNF2 31
18 SO
BBIN2 30
AC3
OVERHEAT
DET
BUFFER
Q106
BBNF1 34
SP R-CH
R-CH
SWITCH
Q351,Q352
SAOUT2 55
BUFFER
Q327
11 TAPEB1
J804
VIDEO
FAN901
15 REC-OUT1 ASMOUT 40
FAN
DRIVE
Q310-Q312
FRONT SP RELAY
L
R
J801
PHONES
BUFFER
Q107
59 GAME-L
9 TAPEA1
AUDIO
R
R-CH
TU-MUTE
GAME INPUT
SPEAKER
R-CH
MUTE
RELAY+B
TUNER-L
TUNER-R
STK
MUTE
CONTROL
Q101,102
TM901
TUNER
L
OVERLOAD DET
Q481,482
MUTE
Q103
CD-MUTE
JK441
RY441
R-CH
J803
VIDEO OUT
STK MUTE
CONTROL
Q308
DECK-A
HP2 L
24 I-STREEMA/VACS
75 SYSTEM-MUTE
69 AMS
STK
WFR/HP/MIC 19
PROTECT 18
SP DRIVER
IC371
R-CH
HP1 R
SYSTEM CONTORLLER
IC601(1/2)
STK MUTE
CONTROL
Q309,313
AC4
RG333
11 Q5
DECK-B
HRP2 L
12 Q6
Q324
HRP1 R
R-CH
RDS DATA
RDS CLK
+9V
L101
BIAS
OSC
Q321
HE1
RCLK
DATA
7 Q1
9 REC SW
CONT 4
7 P/B SW
SELECTOR
IC201
REC(FWD)
B MODE
REC(REW)
A MODE
B HALF
TBL ADDRESS SENS
OPEN SW
CD NUM SENSOR 73
CD-OPEN/CLOSE 21
CD ENCORDER 20
88 CLK
91 DATA
E-1
E-2
E-3
LM-R
LM-F
LM-R
LM-F
TUNED
TAPE
MECHANISM DECK
7 DATA
8 CLK
SWITCH
Q322,323
CD-MUTE
FRONT SP RELAY
LM-R
LM-F
TM-R
TM-F
STEREO
6 Q0
10 Q4
17 Q11
13
14
15
16
Q7
Q8
Q9
Q10
DATA 3
CLOCK 4
LCH 5
SO
DI
CE
DO
CLK
LCH
67 TUNED
68 STEREO
83
84
85
86
87
TM-R
TM-F
23
22
70
71
DI
CE
DO
CLK
LCH
CAPM+
CAP M DRIVE
Q601
MOTOR
B SOL
B TRIP DRIVE
Q602
SOL-B
A SOL
A TRIP DRIVE
Q603
SOL-A
TAPE B START
TAPE A START
I-REEL-A
I-REEL-B
CD
SECTION
(Page 27)
TM-R
TM-F
VIDEO BUFFER
IC602
11 MP3 STB
3 DATA
18 SO
DO
SO
A HALF
A-PHOTO
B-PHOTO
D
CLK
LCH
SOL-A
SOL-B
MOTOR
4 CLK
5 LCK
• R-CH is omitted due to same as L-CH.
• Signal Path
: TUNER
6 SOL-A
: CD
7 SOL-B
: PB(DECK A)
8 MOTOR
: PB(DECK B)
: REC(DECK B)
: AUDIO
28
28
HCD-RG333/RG441
5-4. BLOCK DIAGRAM — PANEL/POWER SECTION —
SYSTEM CONTROLLER
IC601(2/2)
PT901
POWER TRANSFORMER
S641-S650,SW601
FUNCTION
KEY
25 KEY3
STREM-LED1 82
D401
LED610
S601-S608,S610-S612
FUNCTION
KEY
VH+
VH–
27 KEY1
S621-624,626-630
FUNCTION
KEY
STREM-LED3 80
LED
DRIVER
Q612
STREM-LED2 81
LED
DRIVER
Q611
9 VOLUME-IN1
10 VOLUME-IN2
ENCODER
F908
LED612
26 KEY2
S660
MASTER VOLUME
RG441
LED
DRIVER
Q610
D402
STREM-LED6 77
F904
VL+
LED611
RG441:E2,E51 MODEL
S901
VOLTAGE
SELECTOR
LIVE
220V
240V
LIVE
220V
240V
F905
VL–
LED
DRIVER
Q615
F909
LED615
STREM-LED5 78
LED
DRIVER
Q614
28 SIRDS-IN
STREM-LED6 79
RY901
RG333
LED614
REMOTE
CONTROL 1
RECIEVER
IC610
LED
DRIVER
Q613
B+
LED613
F905
B–
POWER LED 76
A+3.5V
2
LED601
A+3.5V REG
1
IC302
F906
D301-D304
CD
SECTION
(Page 27)
A
SCOR
XTCN
XRST
XLT(CD LAT)
CD-DATA
SENS
CD-CLK
MP3-DO
MP3-DI
MP3-CLK
MP3-CS
MP3-LP
MP3-ACK
MP3-REQ
MP3-RESET
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C15
C14
C13
C12
C11
C10
C9
C8
C7
C6
C5
C4
C3
C2
C1
6 MP3-RESET
4 MP3-REQ
3 MP3-ACK
2 MP3-LP
1 MP3-CS
100 MP3-CLK
99 MP3-DI
98 MP3-DO
97 CD-CLK
96 SENS
95 CD-DATA
94 XLT
93 XRES
92 XTCN
5 SCOR
D+3.5V
SW+3.5V
3 D+3.5V REG 1
IC301
–VFL
G01-G13
D908
REG
Q902
+9V
3
+9V REG
IC303
1
M+9V
3
M+9V REG
IC304
1
FL601
43
45
47
S1-S21
50
52
65
AC3
F907
D305-D308
42
30
FLUORESCENT
INDICATOR
TUBE
AC
IN
F904
D401
VF1
VF2
–VFL
RG333/RG441:AR,MX MODEL
RY901
AC4
D309-D312
VF1
AC
IN
VF2
M+9V
B+ SWITCH
Q314,315
AC4
EVER+9V
RELAY DRIVE
Q361,362
D902-905
+4V
12 I-XT1
X601
32.768kHz
POWER RELAY 74
+3.5V
13 I-XT2
RESET 11
15 CF1
X602
10MHz
RESET
SWITCH
Q605
B+ SWITCH
Q604,616
RESET
3
1
IC604
AC CUT 29
16 CF2
29
29
5
+4V REG
IC603
1
PT902
SUB TRANSFORMER
HCD-RG333/RG441
5-5. CIRCUIT BOARDS LOCATION
SENSOR board
SW board
BD81A board
MOTOR (TB) board
MOTOR (LD) board
DRIVER board
CONNECT board
TRANS board
AMP board
SUB TRANS board
VIDEO OUT board
REM board
PANEL board
MAIN board
6 STREAM LED board
GAME JACK board
LEAD board
30
30
H/P JACK board
HCD-RG333/RG441
5-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Indication of transistor.
C
Q
These are omitted.
B E
Q
B C
E
These are omitted.
Q
B
C
E
These are omitted.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
5-7. WAVEFORMS
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
• 2 : nonflammable resistor.
• C : panel designation.
– PANEL Board –
1
2V/DIV, 10µs/DIV
5.2 Vp-p
30.5 s
IC601
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
2
• A : B+ Line.
• B : B– Line.
• Voltage and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : CD PLAY
: Impossible to measure
∗
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : TUNER (FM/AM)
J : CD PLAY
E : TAPE PLAY (DECK-A)
d : TAPE PLAY (DECK-B)
G : REC
f : AUDIO
• Abbreviation
MX : Mexican model
AR
: Argentine model
E2
: 120 V AC area in E model
E51 : Chilean and Peruvian model
qd
2V/DIV, 40ns/DIV
4.9 Vp-p
100 ns
IC601
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to about
350 °C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow) than
ordinary solder so use caution not to let solder bridges occur such
as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may also
be added to ordinary solder.
31
31
(I-XT2)
qh
(CF2)
HCD-RG333/RG441
5-8. PRINTED WIRING BOARD — CD MECHANISM SECTION (1/2) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
M101
C302
B
IC303
C305
C255
C303
R404
R403
R354
R163
R131
C131
• Semiconductor
Location
Q10
G-6
R161
R151
R204
R133
H
32
32
C185 C186
C162
C122
C132
R143 R141
Q10
R132
C133
R11
R12
C124
C123
Location
F-11
D-8
D-11
B-12
R181
C161
CN101
R13
C18
C11
C15
C111
R10
C134
R121
R111
C17
CN201
R182
C194
R412
R406
IC101
R112
C10
C171
R171
C209
C125
C16
C181
C115
C112
C195
C151
Ref. No.
IC101
IC251
IC301
IC303
R410
C213
C211
C114
C113
R113
R114
C14
R172
G
R401
R409
C172
X171
C203
R407
C163
R173
C196
C174
C201
F
R303 C310
R191
C182
R201
C317
R305
R402
R162
R165
C183
R252
R306
R408
C309
R251
C184
R411
C116
C318
C251
FB301
C308
IC301
C311
C320
R307
C259
C307
R253
C258
R205
R301
R353
C312
C210
M102
C313
IC251
C314
E
R419
C306
R352
R302
D
C252
C257
C212
C315
C316
S101
C260
R405
R313
R351
C
C143
R203
R142
C141
C142
R202
(Page 42)
HCD-RG333/RG441
5-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 50 for IC Block Diagrams.
CN101
C15
TP423
R307
C134
TP122
TP123
C123
R121
TP124
TP15
TP16
R132
C306
IC301
R303
R11
TP17
TP121
C309
TP102
C18
TP125
R141
R351
TP303
TP14
C10
C122
R133
TP302
C308
JPO10
C132
C133
R142
TP13
Q10
C11
C124
C143
TP12
C14
C141
R151
TP11
TP424
C16
R10
R143
R203
C17
R12
C151
IC B/D
TP10
R13
R131
C142
TP304
C307
C131
C125
TP18
TP19
R302
R405
TP427
R404
C310
R419
TP103
R352
R403
R402
R353
TP104
R354
R401
R111
C317
JPO102
C161
R301
TP301
TP105
C318
R313 C315
C112
C113
R305
R113
R114
C114
JPO103
C316
C162
R306
C311
C111
R112
R161
C171
C320
C116
C115
R171
TP177
TP428
IC101
X171
TP429
R172
C174
R173
IC303
C172
TP430
C195
C314
C312
R181
C313
TP431
C185
C181
C186
C182
C183
TP432
TP433
C184
TP167
R182
TP178
FB301
C302
C303
TP166
C305
TP422
TP165
C194
TP162
TP146
TP153
TP147
TP160
R191
TP144
TP145
TP149
TP148
TP142
TP425
S101
R252
JPO004
R251
C251
C258
C259
R165
TP426
C163
R162
C196
C210
CN201
R253
TP186
TP187
TP401
TP402
IC251
TP436
TP403
TP404
TP405
C201
TP406
R163
C209
TP407
R201
TP420
TP408
C203
TP250
R205
(Page 43)
R410
TP415
R409
TP414
R408
TP413
R407
TP412
TP421
TP251
TP416
C252
TP252
R411
TP253
TP417
M102
C257
R406
TP419
R412
C260
C213
TP434
TP410
C212
C211
TP411
TP409
R204
M101
TP435
33
33
C255
IC B/D
HCD-RG333/RG441
5-10. PRINTED WIRING BOARDS — CD MECHANISM SECTION (2/2) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
CN704
CN702
C751
B
CN705
R733
C
R734
C736
Q731
R732
R735
C737
C735
JW710
JW707
JW706
C715
JW705
R713
D711
R701
D701
JW708
C752
JW712
JW709
CN703
R722
R721
CN741
CN721
R702
JW711
C741
D
CN742
R751
R723
R711
E
IC731
R712
CN701
JW713
JW704
JW714
(Page 38)
IC712
IC701
JW703
F
MAIN
BOARD
CN301
CN731
JW702
R731
C731
JW701
G
CN751
• Semiconductor
Location
H
Ref. No.
D701
D711
Location
D-6
D-7
IC701
IC712
IC731
F-6
F-7
E-11
Q731
C-9
34
34
S751
(LEVER SW)
HCD-RG333/RG441
5-11. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 50 for IC Block Diagrams.
IC701
IC B/D
R702
R701
C715
D701
CN721
CN704 C751
M751
IC712
IC B/D
R712
CN751
R713
CN705C752
D711
S751
R711
R751
R734
R735
CN702
CN742
C741
M741
IC731
CN731
R733
(Page 37)
R732
R731
C731
CN741
CN701
Q731
CN751
CN703
R723
R722
R721
C737
C736
C735
RE701
35
35
HCD-RG333/RG441
5-12. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 51 for IC Block Diagram.
CN309
R151
Q101
(Page 43)
R216
R217
R219
R385
R388
R391
R386
R152
R392
C235
R218
R387
JW201
R390 R394
Q311
CN308
D203
D204
Q102
C175
R393
JW202
R162
R157
R395
EP101
FAN901
R389
R153
R154
R155
R158
D205
R156
Q312
C228
Q103
Q104
R231
R227
Q310
R159
R228
R163
R225
C229
R232
C230
R226
D207
R160
R161
R164
R165
D206
C188
D202
R230
R229
R174
R220 R222
CN307
D201
Q105
R223
C186
R167
R170
R166
C189
(Page 46)
C187
R172
C177
C178
R175
R221
C185
C176
R173
C181
R168
C190
C184
C183
C179
R171
R169
IC102
C166
C165
(Page 49)
C290
R141
C162
R142
C164
R139
C289
R138
R204
R272
R203
C153
C160
C161
C152
IC B/D
R105
C106
R101
C105
R103
C151
C150
R205
C103
C102
R206
C214
R210
C222
C206
C148
R198
C146
R107
C110 R108
C193
IC101
C109
C144
C278
R212
C280
C281
R211
C143
R283
FB203
C141
C140
R284
R281
FB202
R282
R209
FB201
(Page 43)
C142
C279
R208
C212
C145
R133
R106
C277
C213
C217
C147
R134
C108
Q306
Q307
C216
R197
R207
R135
C149
C104
CN305
R136
R104
C101
Q305
Q304
C211
C107
R102
C276
R202
C163
R201
C157
C154
R137
C159
C139
FB204
R132
D324
R109
C275
R112
C113
C114
C111
C112
C138
D325
C115
C116
C137
C274 R177
C135
R194
C122
C124
JW311
FB205
R127
C136
C129
C191
R115
C128
C192
R114
C127
R195
C121
C123
C117
C125
C118
R131
R113
D326
CN314
R176
C120
R110
R111
(Page 43)
C119
C271
FB205
Q106
C272
R129
R128
R121
Q107
R116
C132
R117
R254
(Page 37)
36
36
C126
R120
R119
HCD-RG333/RG441
5-13. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 51 for IC Block Diagrams.
(Page 36)
Q362
C270
R361
R362
R364
Q361
R363
R275
D316
R274
Q315
Q314
R323
R321
R253
C252
C312
R324
R322
D215
IC302
C315
C321
C311
C258
C309
C318
C253
D212
R262
D213
Q327
D321
R264
Q321
C241
C308
JW303
R273
R266
D313
IC303
IC304
JW301
C259
R241
IC301
R325
D314
C242
C243
R263
R265
R242
C251
CN303
D315
C244
R243
R252
(Page 46)
D214
C351
Q324
EP301
JW302
D310
D309
D312
D311
JW305
R251
C302
Q351
L101
R356
C301
D308
C306
(Page 49)
R352
C310
D307
D306
R351
R353
R250
C313
C316
R354
R357
D305
D301
D302
C303
C248
R244
C246
Q352
C305
R358
C304
D303
D304
IC B/D
C354
C352
IC201
C374
C375
R245
C371
C264
CN112
HP1
R371
C372
R372
HP2
C249
C265
R384
R373
R313
C373
R312
R374
D322
C353
R306
R375
R382
HRP1
C376
Q308
R381
R376
CN103
C266
R383
C267
R246
R307
R377
HRP2
R311
R247
R308
R378
C288
HE1
R379
IC B/D
Q313
IC371
Q322
R310
R248
C250
R380
Q309
C342
R348
D211
CN302
R347
R343
R213
R214
Q323
R249
R346
R345
R342
R341
R344
CN301
(Page 35)
(Page 40)
37
37
CN101
HCD-RG333/RG441
5-14. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
(Page 42)
6
: Uses unleaded solder.
7
8
9
10
11
12
(Page 34)
(Page 42)
A
• Semiconductor
Location
JW109
JW4
JW5
JW115
R344
R343
R342
R341
JW143
JW144
JW9
JW10
JW11
JW12
JW13
JW26
C181
JW14
JW15
JW17
C178
R161 R165
JW35
R172
Q105
IC302
C190
R254
C189
JW50
C309
D313
C315
C318
JW46
JW105
D203
Q312
JW55
Q311
D202
D204
R232
R223
JW61
JW62
R163
R159
R155 R154
JW54
R231
JW57
C302
D205
R230
R220
JW149
JW204
R227
C230
R222
R221
D201
Q101
R152
R151
R162
JW52
D304
D207
D206
R229
JW148
JW59
CN303
CN307
JW303
JW58
EP101
JW305
C289
JW302
J
(Page 45)
(Page 48)
(Page 44)
38
(Page 47)
38
EP301
D303
R228
JW51
JW56
JW69
LP304
R225
C229
R157
C175
C290
R273
Q310
R226
JW53
JW68
I
R158
JW63
C301
D302
D301
JW65
D308
D306
D305
D309
D311
D310
D312
D307
C304
Q103
Q104
JW47
JW48
JW49
JW70
JW71
JW72
JW73
JW76
JW77
JW74
JW75
Q361
Q314
C303
JW202
C305
JW203
R156
JW64
JW83
D321
JW66
JW67
C306
C235
JW31
R153
Q102
D315
C310
R325
LP302
JW30
C313
C316
R218
JW201
R169
JW33
JW37
JW38
C308
C270
Q315 R323
R275
JW80
D316
R274
R395
R390
R389
R387
R386
R385
CN309
JW29
IC301
JW158
R394 R393
R219
R361
R324
JW301
IC303
Ref. No.
D201
D202
D206
D207
D211
D212
D213
D214
D215
D301
D302
D303
D304
D305
D306
D307
D308
D309
D310
D311
D312
D313
D316
D321
D322
D324
D325
D326
Location
H-8
H-9
H-9
H-9
F-3
G-4
G-4
G-3
G-3
H-6
H-6
H-6
H-7
H-5
H-6
H-6
H-6
H-5
H-5
H-5
H-5
F-6
G-5
H-4
H-3
E-3
E-2
E-2
IC101
IC102
IC201
IC301
IC302
IC303
IC304
IC371
D-5
D-7
E-4
F-6
E-7
F-6
F-5
B-3
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q304
Q305
Q306
Q307
Q308
Q309
Q310
Q311
Q312
Q313
Q314
Q315
Q321
Q322
Q323
Q324
Q327
Q351
Q352
Q361
Q362
G-7
G-7
G-8
G-8
E-9
D-6
D-6
E-3
E-3
D-3
D-3
B-3
B-2
G-9
H-9
H-9
B-2
G-5
G-4
F-5
E-3
E-3
F-3
F-4
G-3
G-3
G-5
G-4
R173
R175 R174
D314
JW82
JW157
R391
H
JW32
C194
IC304
R362
R322
R313
JW85
D322
R388 R392
R216 R217
R321
C321
R363
JW86
JW87
LP303
(Page 42)
C252
R263
D212
D213
C259
JW81
JW88
JW156
JW89
JW90
JW92
JW93
JW91
R364
JW84
D215
R354
Q352
G
R266
R357
Q351
JW27
JW28
C311
R115
C242
R242
C243
C312
JW40
JW41
Q362
JW304
C353
R262
C184
JW78
R253
C253
C258
R352
D214
R265
JW94
C351
R353 R264
R356
Q327
R351
R358
C352
JW20
JW45
C251
R252
JW19
JW24
R241
JW79
R213
JW34
C143
R129
R132
C274
R127
C275
R250
R214
C187
JW44
JW42
Q324
JW95
JW21
JW23
R170
C183
R171
FB205
C123
JW97
JW96
JW22
R160
C129
C125 JW39
C124
R194
R164
C185
JW36
C186
R120 R119
C246
CN103
C137
C132
R121
C266
C267
C176
R168 R167 R166
C179 C177
IC102
Q107
JW16
C148
R134
R131
R176
C139
C146
C144
R116
R117
C122
R114
JW104
C241
C127
C248
C117
C116
R110
JW99
R251
C140
R137
R107 R197
L101
JW103
D211
JW102
C249
R247
R246
C288
C126
C244
R245
JW100
R112
C118
C192
JW101
R249
C250
C114
C128
C120
C119
R195
R243
C113
IC201
JW155
C121
R113
C191
R111
C115
R244 R109
C112
R248
R177 R128 Q106
C164
JW118
R135
JW117
C161
R106
R284
C264
R283
C138
C271 C272
C278
C279
C280
C281
JW159
R108
C109
C166
Q321
R211
C102
R101
C106
C104
R198
C108
C277
C111
Q323 Q322
D326
C193
C136 C135
C103
JW106
C265
CN112
D324
JW98
C206
C105
R102
C107
C211
C101
R103 R104
R282 R281
C110
R205
Q305
C163
C276
R204 R207 R210
Q306
Q304
R203
D325
C141
1
JW141
R206 R105
R201
JW138
C154
C147
C145
10
JW139
JW137
C153
CN308
JW8
R348
C228
R133
C149
C142
C152
IC
Q307
JW135
JW136
R136
C162
C213
R212
R208
R209
C214
JW140
C160
C159
JW142
R202
JW134
D
C212
C216
C222
C217
JW133
F
R139
R138
FB201
E
JW116
JW119
JW120
FB203
FB202
CN305
CN302
JW131
(Page 39)
C157
C151
C150
FB204
JW130
JW311
R346
R347
R345
JW18
R272
JW132
R141
LP301
C165
C342
JW114
JW150
JW129
JW7
CN301
R142
JW128
JW6
CN314
JW113
C188
JW110
C354
C
JW1
JW107
R379
R380
R307
R384
R383
R382
R381
JW145
JW2
JW3
R373
JW124
JW127
CN101
JW112
R378
JW123
JW126
C375
R371
JW125
IC371
R374
R375
R376
R377
JW122
JW121
R312
C371
C373
JW151
C372
C376
R372
R311
B
Q309
R310
C374 R308
Q308
JW108
Q313
R306
JW146
B1
• Semiconductor Location
Ref. No. Location
Ref. No.
D603
C-12
D613
D604
C-12
D614
D605
C-12
D615
D606
E-9
D616
D607
C-11
D620
D608
E-9
D621
D609
E-9
D622
D610
E-10
D623
D611
E-9
D625
Location
E-10
D-10
G-7
G-7
B-7
B-6
B-6
B-6
B-6
Ref. No.
D626
D630
D631
D632
D633
Location
B-6
G-4
D-10
D-10
D-9
IC601
IC602
IC603
C-7
E-12
E-10
H
Ref. No.
IC604
IC610
Location
D-10
A-14
LED601
C-12
Q601
Q602
Q603
Q604
H-7
H-7
H-7
B-11
CN602
Ref. No.
Q605
Q610
Q611
Q612
Q613
Q614
Q615
Q616
39
JW661
Q613
CN605
(Page 42)
Location
D-9
F-9
G-8
G-8
G-8
G-9
G-9
B-11
39
JW657
JW655
Q615
Q614
R706
R713
C655
CN604
(Page 42)
C617
R624
R722
Q612
JW811
JW677
IC603
R720
JW665
S648
R671
C608
JW639
JW637
JW646
S650
R721
S630
S627
JW638
S647
JW606
S628
S649
JW662
S629
JW627
S626
R674
D604
S602
R735
R653
JW641
JR607
R654 R642
R736
D603
R643
R644
R772
D622
R660 R659
JW633
R672
R731
R675
R639
D605
R715
JW616
R640
R641
R687
R638
JW628
JW611
R683
R656 R655
JW636
JW612
Q604
R634
C615
JW613
Q616
R684
JR624
R737
C628
R738
C629
C630
A
CN610
11
R633
C603
JW679
JR609
D633
C604
JW632
C601
C602
JW635
JW642
JW664
JW603
R632
C614
JW607
C644
JW629
D631
JW640
JR614
JW625
JW634
JW608
D614
C619
R658
R657
JW663
R661
JW618
R662
JW678
JW619
JW620
D607
JW617
C605
R791
JW630
R689
JW614
JW643
C611
Q605
C656
JW621
JW622
JW687
C631
R739
C632
R740
C633
R741
R742
10
JW631
R682
JW623
JW624
JW686
JW688
C649
JW644
R688
JW690
JW691
JW694
JW626
D632
IC604
R686
R854
R714
C623
JW647
D608
JW680
CN608
R743
C634
R744
C635
9
JW648
JW645
D613
D610
JW815
C646
JW651
D606
JW676 C606
R863
R685
JW652
JW666
C609
C610
R788
R711
R710
Q610
JW656
JW653
JW654
JW667
R679
JW693
R745
C636
R746
C637
C638
C639
R747
C640
R748
R750
R749
R752
R751
R753
R755
R754
R757
R756
R759
R758
R761
R760
R762
R764
R763
R766
R765
R768
R767
R770
R769
8
R698
Q611
C653
R733
R681
JW703
D611
D609
JW669
R680
X602
C607
C654
JW692
C642
JW681
C624
C626
1
FL601
JW668
JW672
R730
R729
JW682
C625
60
JW695
JW671
C613
JR611 JR612
R732
JW670
R631
JW683
R727
X601
JW658
JW673
JW684
JW719
JW659
JW674
IC
R792
R702
JW660
R728
C643
R704
JW720
JW685
R630
JW813
D620
D623
R716
R717
R718
7
R712
C618
JW740
R725
JW712
R637
R787
R636
D621
JW696
R700
D616
R723
R623
S646
JW675
JW716
JW713
JW714
R784
D615
S645
JW736
R796
JW701
JW702
JW697
JW737
JW715
JW814
JW704
JW698
R621
JW750
JW739
D630
JW738
JW728
JW717
JW718
C612
JW729
JW721
JW705
JW706
R615
JW730
R771
JW805
JW806
JW807
R719
6
R626
Q602
JW746
JW722
JW700
JW802
JW803
D625
R625
R622
JW745
JW723
JW708
JW707
JW804
C641
C647
D626
Q603
S644
JW725
WIRE806
R773
R616
R617
S610
R601
R618
R799
R798
R677
JW731
JW726
JW709
JW782
JW724
JW727
JW800
JW801
C620
R794 JW699
R793
JW743
R607
R608
JW810
JW710
JW711
S603
JW732
JW733
JW770
R774
5-15. PRINTED WIRING BOARDS — PANEL SECTION — • Refer to page 30 for Circuit Boards Location.
R708
JW748
R795
R619
S611
JW769
JW792
JW734
JW735
R669
JW793
R605
R663
R775
R777
R776
R778
R781
R785
R783
C622
JW744
R678
JW760
R789
JW794
R609
R652
JW799
R604
R697
JW773
JW795
JW751
S612
JW772
JW771
JW796
R670
JW789
JW774
JW797
R610
R790
R664
JW776
S642
JW775
R665
JW753
S643
JW777
JW781
JW757
JW788
JW754
R666
JW790
5
JW741
JW747
4
R611
R613
R602
R603
R606
G
CN603
R797
R676
R696
JW798
C621
R612
JR622
JR617
JW808
(Page 42)
JW752
R695
S641
JW755
R694
JW759
JW780
JW812
R691
R667
R782
JW756
R692
JW758
R690
JW761
JW778
JW784
JW763
JW787
R668
R635
R734
R628
R627
JW762
JW602
3
R614
C648
JR623
JW765
R780
R779
JW791
R620
S608
JW786
R629
R651
CN601
JW779
JW783
JW764
(Page 38)
JW785
JW809
2
JR621
Q601
JW749
R693
JW766
S606
E
JW768
D
JW767
F
S607
S604
R649
R650
C
R645
JW601
B
R648
S605
R646
1
Administrator SV-HCDRG333-PANEL
R647
HCD-RG333/RG441
: Uses unleaded solder.
12
13
R786
JW689
LED601
S601
JW615
JW610
S621
S622
IC602
JR608
S623
S624
14
IC610
HCD-RG333/RG441
5-16. SCHEMATIC DIAGRAM — PANEL SECTION (1/2) — • Refer to page 51 for IC Block Diagram.
CN605
R704
R706
R708
(Page 43)
R700
JW660
R702
JW659
Q610
CN604
Q612
Q611
Q614
Q615
Q613
R698
JW674
JW718
(Page 43)
JW705
JW655
JW656
JW658
CN601
JW784
D605
JW783
JW601
JW602
R629
R628
(Page 41)
R639
D604
R640
R627
C605
R641
D603
R854
R690
R691
R672
R731
JW811
R692
R693
R638
R694
R695
R696
R697
IC B/D
C655
R674
IC602
R663
R652
R651
R650
R649
R648
R647
R646
R645
R644
R643
R642
R635
S612
S611
S610
S608
S607
S606
S605
S604
S603
S602
S601
C602
C603
JR607
JR609
JR608
R634
R633
JW714 JW635
C601
JW701
C604
JW625
JW626
C644
JW716
R632
JW641
JW703
(Page 37)
R662
S630
R722
R721
S650
40
40
R661
R660
R659
S629
S628
S627
R720
S649
R671
S648
R658
R657
S626
R670
R669
S647
S646
R656
R655
S624
R668
S645
R667
S644
S623
R666
S643
R665
S642
R654
R653
S622
S621
R675
R664
S641
R676
HCD-RG333/RG441
5-17. SCHEMATIC DIAGRAM — PANEL SECTION (2/2) — • Refer to page 31 for Waveforms.
FL601
CN603
JW812
R785
R783
C629
C623
C628
C632
C631
C630
C634
C635
C633
C638
C637
C636
C640
C639
R751
R750
R753
R752
R756
R755
R754
R759
R758
R757
R762
R761
R760
R764
R763
R767
R766
R765
R770
C622
R780
R769
R781
R768
R782
R779
(Page 43)
R710
R712
LED601
R778
C620
R719
C621
R777
R772
R718
R771
C642
R711
R713
C617
C618
R602
R601
R605
R604
R603
R607
R608
D621
D620
JW721
D622
JW673
D625
JW722
D623
JW723
JW729
D626
JW724
JW728
R793
JW670
R792
R717
R794
R716
JR617
R796
R774
R606
R776
R775
R621
JW706
R622
R795
JW708
JW709
JW707
JW606
Q601
JR621
R790
R609
R610
R611
CN602
R797
R773
JW607
R624
R789
R613
R612
R623
Q602
R614
C641
R615
D615
R798
R749
C643
R748
IC601
R616
R617
R747
53H2
R746
JW608
R626
R625
R799
R745
R618
R744
R784
R619
Q603
R743
R620
R742
R741
D616
R740
R787
R739
R738
R637
R636
IC610
CN608
R714
R734
R735
R736
R791
R733
R727
C626
R728
R788
R737
R730
R630
R631
R725
R723
R729
JR624
(Page 40)
R715
CN610
C619
R732
C654
D611
C607
C625
C610
C647
R681
C653
X601
JR611
D607
JR612
X602
C624
C649
R680
C611
D609
R682
D608
D630
R677
Q605
R678
IC603
R687
R863
C648
R686
C612
R679
D606
C646
C606
C608
C613
C609
C656
R685
D633
C614
Q604
R689
R786
R683
R684
D632
D610
C615
D631
41
41
IC604
R688
Q616
WIRE806
D614
D613
HCD-RG333/RG441
5-18. PRINTED WIRING BOARDS — JACK SECTION — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
: Uses unleaded solder.
7
8
9
10
11
12
13
14
LED613
JW874
R701
SW
60
R699
1
LED615
C
(Page 38)
S660
R709
CN871
(Page 38)
J801
(Page 39)
LED611
CN874
JW873
R707
C831
JR871
JW876
JW878
C832
C830
R703
R673
JW877
R705
JW875
C873
LED614
B
JW872 JW879 JR872
JW871
LED612
W803
CN804
CN607
(Page 39)
CN873
FB871
FB872
JW831
C872
C871
C876
C875
C874
A
LED610
CN606
D
LP872
LP874
LP871
LP873
(Page 39)
E
(Page 32)
F
G
CN801
(Page 38)
C804
WIRE801
C803
R801
R804
C801
JR801
R803
J804
LP804
LP802
W806
EP802
CN802
H
42
C861
J803
CN805
R802
C802
42
• Semiconductor
Location
Ref. No.
LED610
LED611
LED612
LED613
LED614
LED615
Location
C-9
B-9
A-9
A-7
B-7
C-7
HCD-RG333/RG441
5-19. SCHEMATIC DIAGRAM — JACK SECTION —
C830 C831
CN874
S660
SW601
CN804
JW877
R709
(Page 36)
LED615
R705
R701
R703
R707
LED614
R673
LED613
(Page 36)
JW878
LED612
FB871
JW875
LED610
JW876
CN871
LED611
R699
J801
C832
FB872
JW871
W803
JW872
CN873
JW873
CN606
CN607
JW874
(Page 33)
JW879
C874
(Page 40)
(Page 40)
CN805
CN802
C876
C875
C873
C872
C871
(Page 41)
J803
JR872
R801
JR871
R803
C801
R804
C802
J804
JR801
C804
C803
R802
CN801
C861
(Page 36)
WIRE801
43
43
EP802
W806
HCD-RG333/RG441
5-20. PRINTED WIRING BOARD — POWER AMP SECTION (RG333) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
8
A
• Semiconductor
Location
R483
Q481
C481
R493
D483
B
R467
R491
Q489
R486
R484
JW471Q483
R485
Q482
R492
R465
R466
R494
C488
JW468
Q484
TH441
JW466
JW403
JW465
JW461
R453
JW464
R496
JW432
R451
JW404
JW462
C451
C453
JW469
C
R454
R455
JW458
JW457
JW455
JW456
JW452
JW453
JW446
JW447
JW454
C405
JW436
JW435
JW401
C403
JW444
JW445
D401
LP401
JW417
C406
JW416
JW419
R402
C458
(Page 45)
JW412
JW411
JW409
R407
JW407
D443
JW408
R461
L441
L442
R462
JW415
RY441
JW472
JW400
JW418
C457
C455
JW413
C456
R464
CN442
JW443
C404
JW421
JW414
JW420
C459
JW434
JW433
C460
JK441
C407
C408
I
R401
C402
R463
JW402
EP402
JW423
Q487
EP401
R489
JW422
R488
R457
R459
D481
Q486
C486
D441
R458
D482
R487
R482
D442
JW427
R490
JW474
JW437
Q485
G
Q441
Q442
R456
R460
R411
JW426
R412
JW439
JW438
JW473
C487
R481
JW440
JW425
R448
Q488
R442
C491
JW424
R414
C442
R444
C444
C448
JW449
JW442
JW451
R446
JW429
JW428
C441
R443
C443
C447
C446
R441
R413
F
JW431
R495
C489
IC441
R445 C445
JW450
C452
R447
JW441
E
JW430
JW463
JW460
R452
JW459
C454
D
Ref. No.
D401
D441
D442
D443
D481
D482
D483
Location
H-6
E-5
E-4
J-4
E-5
G-4
B-4
IC441
D-3
Q441
Q442
Q481
Q482
Q483
Q484
Q485
Q486
Q487
Q488
Q489
D-5
D-4
B-4
B-4
B-5
B-5
G-3
G-4
G-4
F-4
B-4
JW470
JW467
H
: Uses unleaded solder.
JW410
CN441
J
(Page 38)
44
44
HCD-RG333/RG441
5-21. PRINTED WIRING BOARDS — TRANSFORMER SECTION (RG333) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
JW918
LP903
CN902
CN906
C
LP901
C910
C909
D908
D901
C911
CN904
C908
D906
D903
R903
D902
R904
B
D905
R908
D904
Q902
C906
JW900
RY901
PT902
PT901
JW923
D
FH907
FH908
E
CN905
(Page 44)
FH909
JW922
JW903
JW906
F904
FH910
F
JW908
C920
FH912
JW929
JW921
CN901
F905
FH911
F906
C921
C922
JW902
C926
C925
JW926
JW924
(Page 38)
FH914
FH913
JW917
H
CN907
JW930
JW920
JW910
G
F907
C924
CN903
C923
LP902
• Semiconductor
Location
I
45
45
Ref. No.
D901
D902
D903
D904
D905
D906
D908
Location
C-3
B-2
B-2
B-2
B-2
C-12
C-10
Q902
C-12
HCD-RG333/RG441
5-22. SCHEMATIC DIAGRAM — POWER SECTION (RG333) —
JW403
C441
L441
RY441
R451
R441
JW441
R461
IC441(1/2)
C445
R413
R466
R462
R465
R411
R464
R463
C456
C455
TH441
L442
R447
R483
R455
R445
R491
R467
C451
Q481
Q482
Q441
R485
C459
D443
Q483
JK441
C458
C457
R484
R407
C460
C453
R443
R444
C444
Q489
C488
C491
0.001
R493
R494
R446
EP401
R486
Q484
C481
R459
C408
C407
R453
C489
C448
D442
C443
R492
D441
D483
C447
R457
R495
D481
R460
Q485
R454
R414
C486
R482
R458
C454
R448
Q442
D401
C452
R481
R456
C446
C402
Q487
JW401
IC441(2/2)
C442
CN441
R487
JW442
C405
R452
R401
C403
Q486
JW404
R490
R488
R412
C487
D482
R442
Q488
C406
C404
JW402
R402
R489
R496
JW407
(Page 36)
EP402
CN442
PT901
F904
FH908
CN905
FH907
F905
CN904
FH910
FH909
FH912
FH911
CN907
CN903
JW908
JW902
RY901
D901
F906
JW910
F907
FH914
(Page 37)
PT902
FH913
R908
CN902
D908
D903
D902
JW903
CN906
Q902
D905
C908
D906
C924
C925
C926
C922
C923
C920
C921
C910
CN901
JW917
R903
R904
D904
JW906
C906
C911
C909
46
46
HCD-RG333/RG441
5-23. PRINTED WIRING BOARD — POWER AMP SECTION (RG441) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
C492
R483
Q484
R484
Q483
R486
• Semiconductor
Location
EP491
JW453
R457
D481
C481
R466
R465
JW446
Q442
JW404
C445
R446
EP402
JW412
JW409
LP401
CN442
C403
JW410
D401
R409
LP402
C413
C404
R410
JW415
JW475
JW474
JW477
C406
D402
C4
JW483
JW414
JW424
JW425
R404
JW413
JW401
09
JK441
(Page 48)
C414
R402
JW426
JW427
JW411
C405
R490
R489
R488
Q487
C402
JW482
Q488
Q486
JW418
JW417
Q485
EP401
D482
JW471
JW470
R447
R487
R482
JW488
JW479
JW473
JW472
C486
C487
R481
JW481
JW487
JW478
R403
JW430
JW431
R401
JW428
JW429
C441
C447
H
JW458
JW455
JW469
JW468
R412 C442
R413
R414
R445
R441
R411
JW441
C443
R443
R453
R454
10
R444
R442
G
C454
C448
C446
C444
F
C452
R448
JW442
E
JW467
JW466
C453
R476
JW447
D442
R460
C451
R458
JW445
JW465
R456
R459
Q441
JW457
IC441
R449
JW460
JW486
JW459
JW448
Q482
JW403
JW485
Q481
D441
JW449
JW461
JW462
R455
R450
R474
JW451
JW450
JW464
R495
JW420
JW421
CN441
J
(Page 38)
47
47
LP403
JW422
JW423
R407
JW432
R461
RY441
JW419
D443
R462
I
L442
L441
JW489
JW416
JW476
LP404
D
R478
Q491
R496
JW452
JW463
C
C463
R470
R473
R475
JW443
D445
JW484
D446
Q489
TH441
Q490
C461
R472
D444
R469
R477
R471
C4
B
R467
R468
C462
R485
A
Ref. No.
D401
D402
D441
D442
D443
D444
D445
D446
D481
D482
Location
G-8
H-9
C-4
D-5
I-4
B-5
C-3
C-3
D-5
G-4
IC441
D-3
Q441
Q442
Q481
Q482
Q483
Q484
Q485
Q486
Q487
Q488
Q489
Q490
Q491
D-4
D-4
D-4
D-4
A-4
A-4
G-3
G-4
G-4
F-4
B-4
C-5
C-5
HCD-RG333/RG441
5-24. PRINTED WIRING BOARDS — TRANSFORMER SECTION (RG441) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
8
: Uses unleaded solder.
9
10
11
12
13
14
A
LP903
D904
D905
D902
D903
CN904
JW911
CN906
CN902
B
D901
C911
Q902
C906
D908
R908
C909
C
C908
R904
LP901
R903
C910
JW912
D906
FH916
RY901
FH915
PT902
JW923
F908
JW905
D
PT901
FH908
CN905
F905
F909
JW909
CN907
(Page 38)
C926
C922
C921
C920
C925
C923
W901
C924
LP902
JW929
JW928
JW917
JW902
JW930
JW934
JW932
JW924
FH914
FH913
F907
JW931
JW933
F906
JW920
JW910
JW901
CN903
FH912
FH911
S901
G
H
FH917
FH918
CN901
JW921
JW908
F
(Page 47)
FH910
FH909
JW907
JW925
E
F904
JW922
JW903
JW906
FH907
• Semiconductor
Location
I
48
48
Ref. No.
D901
D902
D903
D904
D905
D906
D908
Location
B-3
B-2
B-2
B-2
B-2
C-13
C-10
Q902
B-12
HCD-RG333/RG441
5-25. SCHEMATIC DIAGRAM — POWER SECTION (RG441) —
C461
R496
R467
D445
L441
R411
C441
R449
R474
R441
RY441
JK441
R461
Q491
JW441
R462
IC441(1/2)
R466
C445
JW403
R472
R473
R465
L442
C451
R455
TH441
D443
R485
Q483
C453
R483
R413
Q489
EP491
Q490
R447
R470
D444
R486
R445
Q441
R457
R469
Q484
C463
R443
C447
R475
C492
D441
R471
C443
R407
R484
Q482
C481
R459
Q481
R453
D401
R444
C462
R468
C448
R495
R478
R460
D442
C444
D481
EP402
D402
R477
CN441
R458
R454
R448
R414
Q485
R403
R456
C413
C409
R401
C486
R482
C454
D446
JW411
R409
R481
C405
C403
JW409
C452
(Page 36)
R487
JW404
JW442
C442
Q487
IC441(2/2)
R442
C446
C406
R490
C404
R410
Q488
Q486
C414
D482
R412
R450
C487
R488
C410
R489
R404
CN442
R402
F908
FH916
FH915
CN905
F904
FH908
FH907
FH909
FH910
JW907
CN904
F905
CN903
JW901
FH917
FH912
CN907
FH918
JW908
JW912
F909
JW902
FH911
JW910
S901
JW909
RY901
D901
F906
FH914
FH913
F907
JW925
R908
D908
(Page 37)
PT902
JW917
Q902
JW903
C926
C925
C924
C923
C922
C921
C920
C910
R904
D906
EP401
Q442
R476
R446
C402
JW401
R903
CN902
PT901
C908
D903
D902
JW906
CN906
C911
C906
CN901
D905
C909
W901
49
49
D904
JW905
HCD-RG333/RG441
5-26. IC BLOCK DIAGRAMS
SFSY
SBSY
DATA
26
TXO
27
VDD
PIO3
28
CKI
PIO4
29
VSS
PIO5
30
PIO0
PIO6
31
IC251 BA5947FM (BD81A BOARD)
PIO1
PIO7
32
PIO2
WE
IC301 TC94A34FG-002 (BD81A BOARD)
25
24
23
22
21
20
19
18
17
CH4OUTF 20
D
CH3OUTF 21
D
LEVEL
SHIFT
D
18 CH1PUTF
D
17 CH1OUTR
D
16 CH2OUTF
D
15 CH2OUTR
Sub code
I/F
DIT
Audio I/F
POW
VCC
(ch1, 2)
50k 50k
50k 50k
POW
VCC
GND 25
GND 26
12 GND
11 C-M
10 C-P
CT 28
ALU
round & limit
A3
AY
A2
AX
11 SDO0
MZ
round & limit
A1
A0
MAC
MY
OUTVREF 33
9 VDDT
F
9 VG
R
R
INTER
FACE
8 CH2RIN
INTER
FACE F
F
7 CH2FIN
R
100k
10 VSS
CH4CAPA 32
MX
F
CH3FIN 30
CH4IN 31
F
R
R
CH3RIN 29
register
XO • X1 • X2
Y0 • Y1 • Y2
14 POWVCC
13 CNF4
Vref
MUTE
Y-Bus
X-Bus
C-Pointer
register
Vref
PREGND 27
ERAM
2k word
SRMSTB 41
10k
50k 50k
12 BCKO
CRAM
4k word
VDDM 40
MUTE 24
13 LRCKO
CROM
4k word
AD11 39
14 SDI0
PIN26
6.5k
D
POW
VCC
(ch3, 4)
POWVCC 23
X-Pointer
register
CDP Cont
I/F
CCE 37
19k
CH3OUTR 22
15 BCKIA
Y-Pointer
register
Address Calc.
2sets
BUCK 36
AD12 38
1Mbit
SRAM
SRAM I/F
General
In/Output Port
SRAM/
DRAM I/F
OE 35
D
16 LRCKIA
RAS 33
CAS 34
CH4OUTR 19
6 CH1RIN
INTER
FACE
PIN3
5 CH1FIN
F
10k
50k
SW
4 SW
3 OPIN+
DPOUT 34
8 MIACK
Pre
Vcc
TREVCC 35
2 OPIN-
NC 36
VDDT 42
1 NC
MCU. I/F
YRAM
4k word
7 MICK
6 MIDIO
Program
Control
XRAM
4k word
AD10 43
AD9 44
Bus
Switch
5 MILP
IC701 BA6956AN (DRIVER BOARD)
IC712 BA6956AN (DRIVER BOARD)
AD8 45
PRAM
POM
AD7 46
Instruction
Decoder
4 MICS
TSD
3 STANBY
AD6 47
2 RESET
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
50
50
AD4
AD3
AD2
AD1
AD0
VSS
VDD
CKO
VDDX
XO
XI
VSSX
TEST
MIMD
VSSP
VCOI
1
2
3
4
5
6
7
8
9
RNF
OUT1
VM
VCC
FIN
GND
RIN
1 VDDP
Timing
Generator
VC0
OUT2
AD5 48
VREF
CONTROL LOGIC
HCD-RG333/RG441
MNF2
MOUT2
MOUT1
MNF1
BNF1
BOUT1
BOUT2
BNF2
AMS OUT
TONE OUT2
VIN2
TONE OUT1
VIN1
BBIN1
BBNF1
VOLOUT1
IC101 BD3401KS2 (MAIN BOARD)
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
TNF1
BASS
MIDDLE
+
-
+
-
TNF2 49
TREBLE
32 VOLOUT2
+
-
50
31 BBNF2
+
SUR1 51
BASS
MIDDLE
+
TREBLE
30 BBIN2
+
-
SURROUND
29 LF1
SUR2 52
+
-
28 LF2
f
0
LINEOUT1 54
+
27 LF3
BUFFER
MIX
MIC MIX
VOCAL FADER
SAOUT2 55
26 LF4
Di-LIMITER
+
-
fc=100HZ
+
-
LINEOUT2 53
G
ATT
ATT
SAOUT1 56
+
SOFT
SWITCH
CAP 57
+
-
25 SWOUT
+
-
24 FILTER
+
-
MIC 58
23 1/2 Vcc
+
-
22 Vcc
GAME R 60
+
-
21 GND
+
-
+
-
GAME L 59
TUNER L 61
20 VDD
19 SI
DIGITAL
CONTROL
INPUT
SELECTOR
TUNER R 62
+
-
+
-
MD L 63
18 SC
ALC
ALC
17 ALC
TAPE R
PBNF2
PBOUT2
PBOUT1
PBNF1
12
13
14
15
16
RECNF1
TAPE L
11
+
-
CD R
10
VCC
PB SW2
GND
REC SW2
V DD
OE
SO
Q11
Q10
Q9
Q8
Q7
Q6
Q5
12BIT STORAGE
RAGESTER
OUTPUT BUFFER (Open Drain)
1
2
3
4
5
6
7
8
9
10
Q4
GND
12BIT SHIFT REGESTER
Q3
CONT
11
Q2
PB SW1
12
Q1
9
13
Q0
8
14
LCK
7
15
L. P. F
6
16
CLOCK
5
17
CONTOROL
CIRCUIT
4
18
DATA
3
19
N.C.
2
20
V SS
1
GND
IC371 BU2099FV (MAIN BOARD)
IC602 BU2099FV (PANEL BOARD)
REC SW1
IC201 BA3126N (MAIN BOARD)
9
RECOUT1
8
RECOUT2
7
RECNF2
6
TAPE B2
5
TAPE B1
4
TAPE A2
3
TAPE A1
+
-
2
+
-
+
-
1
CD L
MD R 64
51
HCD-RG333/RG441
SECTION 6
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Accessories are given in the last of this
parts list.
• Abbreviation
MX : Mexican model
AR : Argentine model
E2 : 120 V AC area in E model
E51 : Chilean and Peruvian model
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
6-1. MAIN SECTION
not
supplied
#1
5
b
b
#1
1
#1
not supplied
(VIDEO OUT board)
#1
#1
#1
4
8
#1
CDM74-F1BD81
#1
1
#1
#1
not
supplied
#1
3
a
6
FAN901
7
not
supplied
#1
TM901
#2
#1
#1
not
supplied
1
#1
chassis section
#2
2
not
supplied
front panel section
1
#2
Ref. No.
Part No.
Description
1
2
3
4
4
3-363-099-32
4-245-184-71
4-245-183-71
4-252-196-61
4-252-196-71
SCREW (CASE 3 TP2)
CASE (SIDE-R)
CASE (SIDE-L)
DOOR, CD (RG333)
DOOR, CD (RG441)
5
6
7
7
4-244-849-71
1-400-285-11
1-769-940-11
1-777-353-11
CASE (TOP)
F-BEAD, E2515MRT
WIRE (FLAT TYPE) (11 CORE) (RG441)
WIRE (FLAT TYPE) (15 CORE) (RG333)
52
Remark
Ref. No.
Part No.
Description
Remark
8
8
X-4956-293-1 SUB TRANS BOARD, COMPLETE (RG333)
X-4956-294-1 SUB TRANS BOARD, COMPLETE
(RG441:E2,E51,AR)
8
X-4956-322-1 SUB TRANS BOARD, COMPLETE (RG441:MX)
FAN901 1-763-117-13 FAN, DC
TM901 1-693-615-11 TUNER PACK (FM/AM) (ANTENNA) (RG441)
TM901
#1
#2
1-693-616-11 TUNER PACK (FM/AM) (ANTENNA) (RG333)
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
HCD-RG333/RG441
6-2. FRONT PANEL SECTION (1)
51
not supplied
(REM board)
55
54
FL601
56
51
53
not supplied
(GAME JACK board)
not supplied
(LEAD board)
51
not supplied
not supplied
52
51
51
not supplied
(H/P JACK board)
Ref. No.
51
52
53
54
Part No.
Description
4-951-620-01
1-796-485-51
1-769-975-11
1-773-048-11
SCREW (2.6X8), +BVTP
DECK, MECHANICAL
WIRE (FLAT TYPE) (13 CORE)
WIRE (FLAT TYPE) (17 CORE)
Remark
Ref. No.
55
55
56
FL601
Part No.
Description
A-4751-547-A
A-4751-553-A
1-773-317-11
1-518-976-11
PANEL BOARD, COMPLETE (RG333)
PANEL BOARD, COMPLETE (RG441)
WIRE (FLAT TYPE) (31 CORE) (RG333)
INDICATOR TUBE, FLUORESCENT
Remark
53
HCD-RG333/RG441
6-3. FRONT PANEL SECTION (2)
104
not supplied
105
not supplied
103
101
102
103
Ref. No.
101
102
103
54
Part No.
Description
4-231-841-01 SPRING (HEART CAM-B)
4-231-825-01 CAM (B), HEART
4-224-104-41 DAMPER
Remark
Ref. No.
104
105
Part No.
Description
4-231-824-01 CAM (A), HEART
4-231-836-01 SPRING (HEART CAM-A)
Remark
HCD-RG333/RG441
6-4. FRONT PANEL SECTION (3)
157
156
155
153
not supplied
not supplied
not supplied
162
161
160
154
not
supplied
159
158
not supplied
(6 STREAM LED board)
163
not supplied
not supplied
not supplied
153
not supplied
152
not supplied
Ref. No.
Part No.
Description
151
152
153
154
155
4-252-202-01
4-252-201-01
4-951-620-01
4-252-214-01
X-4956-295-1
DOOR (B), CASS
DOOR (A), CASS
SCREW (2.6X8), +BVTP
KNOB, VOLUME
RING ASSY, KNOB
156
156
4-252-198-01 WINDOW, DISPLAY (RG441)
4-252-198-11 WINDOW, DISPLAY (RG333)
151
Remark
Ref. No.
Part No.
Description
157
158
159
160
161
4-252-195-31
4-252-205-01
4-252-207-11
4-252-200-01
4-252-208-11
PANEL, FRONT
BUTTON, PLAY
BUTTON, FF/ALBUM+
COVER, BUTTON
BUTTON, FR/ALBUM–
162
163
4-252-206-01 BUTTON, STOP
4-225-252-01 CUSHION (FOOT)
Remark
55
HCD-RG333/RG441
6-5. MAIN BOARD SECTION
#4
203
#3
204
not supplied
201
202
209
PT901
203
201
206
not supplied
205
F908
207
208
F905
F904
F906
F907
F909
not supplied
#2
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
Ref. No.
Part No.
201
202
202
202
202
4-242-527-01
A-4751-549-A
A-4751-555-A
A-4752-193-A
A-4752-198-A
S-SCREW, ITC+4-8 R
AMP BOARD, COMPLETE (RG333)
AMP BOARD, COMPLETE (RG441:E2,E51)
AMP BOARD, COMPLETE (RG441:MX)
AMP BOARD, COMPLETE (RG441:AR)
0 F904
203
204
205
* 205
0 206
4-242-539-01
3-905-609-41
3-703-244-00
3-703-571-12
1-777-071-83
BVIT3B+3-8R W/O SLOT
SCREW (TRANSISTOR)
BUSHING (2104), CORD (EXCEPT RG441:E2,MX)
BUSHING (S) (4516), CORD (RG441:E2,MX)
CORD, POWER (RG333,RG441:E51)
0 F905
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V)
(RG441)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG333)
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V)
(RG441)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG333)
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
0 206
0 206
207
208
208
1-783-941-22
1-827-226-11
4-988-533-01
A-4751-788-A
A-4752-183-A
CORD, POWER (RG441:AR)
CORD, POWER (RG441:E2,MX)
HOLDER, PWB
MAIN BOARD, COMPLETE (RG333)
MAIN BOARD, COMPLETE (RG441)
209
209
209
209
A-4750-766-A
A-4751-524-A
A-4752-191-A
A-4752-196-A
TRANS BOARD, COMPLETE (RG333)
TRANS BOARD, COMPLETE (RG441:E2,E51)
TRANS BOARD, COMPLETE (RG441:MX)
TRANS BOARD, COMPLETE (RG441:AR)
56
Remark
0 F904
0 F905
0 F906
0 F907
0 F908
Description
Remark
0 PT901
0 PT901
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG441)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG441)
1-443-234-11 TRANSFORMER, POWER (RG333)
1-443-255-11 TRANSFORMER, POWER (RG441:E2,E51,AR)
0 PT901
#2
#3
#4
1-443-294-11
7-685-646-79
7-685-649-79
7-685-881-09
0 F909
TRANSFORMER, POWER (RG441:MX)
SCREW +BVTP 3X8 TYPE2 IT-3
SCREW +BVTP 3X14 TYPE2 IT-3
SCREW +BVTT 4X8 (S)
HCD-RG333/RG441
6-6. CD MECHANISM SECTION (1)
(CDM74-F1BD81)
256
262
258
251
256
257
256
257
263
259
258
261
264
264
265
260
255
255
M741
252
254
253
266
CD mechanism deck section-2
251
Ref. No.
Part No.
Description
251
252
253
254
255
4-218-253-21
1-776-182-11
1-687-134-12
4-243-815-01
4-245-571-02
SCREW (M2.6), +BTTP
WIRE (FLAT TYPE) (5 CORE)
MOTOR (TB) BOARD
TABLE (LOADING)
GEAR (STOPPER)
256
257
258
259
4-218-252-61
4-245-570-01
4-245-572-01
1-687-132-12
SCREW (+PTPWH M2.6), FLOATING
GEAR (JOINT)
BUSHING (GEAR)
SENSOR BOARD
Remark
Ref. No.
Part No.
Description
260
261
262
263
264
4-243-820-01
4-243-819-01
4-243-816-01
4-243-823-01
4-985-672-01
GEAR (TABLE)
GEAR (GENEVA)
TRAY
BELT (TABLE)
SCREW (+PTPWH M2.6), FLOATING
265
266
M741
4-243-821-01 PULLEY (TABLE)
3-231-598-01 SHEET (BA)
A-4723-963-A MOTOR ASSY, TABLE (TBL)
Remark
57
HCD-RG333/RG441
6-7. CD MECHANISM SECTION (2)
(CDM74-F1BD81)
315
308
316
308
319
317
314
320
308
318
313
322
321
323
RE701
304
308
312
325
308
324
328
M751
301
325
325
324
324
326
311
309
325
324
326
310
302
304
303
308
327
329
330
305
307 not supplied
(CONNECT board)
not supplied
FC901
306
327
326
S101
304
332
331
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
301
302
303
304
305
1-471-035-11
X-4955-707-2
1-687-135-12
4-218-253-31
A-4751-431-A
MAGNET ASSY
PULLEY (A5) ASSY, CHUCKING
DRIVER BOARD
+BTTP M2.6
BD81A BOARD, COMPLETE
306
307
308
309
310
4-951-620-01
4-244-034-01
4-218-252-61
4-225-844-01
1-687-669-12
SCREW (2.6X8), +BVTP
BELT (LOADING)
SCREW (+PTPWH M2.6), FLOATING
GEAR (LOADING A)
SW BOARD
311
312
313
314
315
4-224-613-01
1-687-133-12
4-244-108-01
4-224-609-01
4-224-608-01
GEAR (SHAFT)
MOTOR (LD) BOARD
GEAR, SWING
GEAR (LOADING C)
COLLAR, SWING
316
317
318
3-016-533-11 WASHER (FR), STOPPER
4-224-611-01 GEAR (LOADING B)
4-224-606-01 GEAR (RV)
58
Remark
Ref. No.
Part No.
Description
Remark
319
320
321
322
323
4-243-818-01
4-243-822-02
4-243-817-01
4-231-189-01
X-4955-536-1
GEAR (U/D)
LEVER (LIFTER)
CHASSIS
PULLEY (B), CHUCKING
HOLDER (213) ASSY
324
325
326
327
0 328
4-227-045-31
4-227-549-11
4-231-151-01
4-218-253-31
8-820-244-01
SPRING (INSULATOR), COIL
INSULATOR
STOPPER (BU)
+BTTP M2.6
OPTICAL PICK-UP (KSM-215DCP/C2RP)
329
330
331
332
FC901
1-827-992-11
1-775-251-11
4-951-620-01
4-985-672-01
1-469-854-11
WIRE (FLAT TYPE) (16 CORE)
WIRE (FLAT TYPE) (27 CORE)
SCREW (2.6X8), +BVTP
SCREW (+PTPWH M2.6), FLOATING
CORE, FERRITE
M751
RE701
S101
A-4736-655-A MOTOR ASSY, LOADING (LOADING)
1-477-680-12 ENCODER, ROTARY
1-771-853-11 SWITCH, DETECTION (LIMIT)
HCD-RG333/RG441
SECTION 7
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
Ref. No.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
• Abbreviation
MX : Mexican model
AR : Argentine model
E2 : 120 V AC area in E model
E51 : Chilean and Peruvian model
Part No.
Description
Remark
A-4751-549-A
A-4751-555-A
A-4752-193-A
A-4752-198-A
AMP BOARD, COMPLETE (RG333)
AMP BOARD, COMPLETE (RG441:E2,E51)
AMP BOARD, COMPLETE (RG441:MX)
AMP BOARD, COMPLETE (RG441:AR)
*********************
Ref. No.
AMP
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board.
Part No.
Description
Remark
C452
C453
C454
C455
1-136-497-81
1-136-497-81
1-136-497-81
1-136-497-81
FILM
FILM
FILM
FILM
0.1uF
0.1uF
0.1uF
0.1uF
5%
5%
5%
5%
C456
1-136-497-81 FILM
0.1uF
5%
C457
1-136-497-81 FILM
0.1uF
5%
C458
1-136-497-81 FILM
0.1uF
5%
C459
1-162-294-31 CERAMIC
0.001uF
10%
C460
1-162-294-31 CERAMIC
0.001uF
10%
C461
1-128-562-11 ELECT
47uF
20%
C462
1-128-562-11 ELECT
47uF
20%
C463
1-104-655-91 ELECT
470uF
20%
C481
C486
C487
1-104-658-91 ELECT
1-126-961-11 ELECT
1-126-963-11 ELECT
100uF
2.2uF
4.7uF
20%
20%
20%
C488
1-126-965-11 ELECT
22uF
20%
50V
(RG441)
50V
(RG441)
50V
(RG441)
50V
50V
C489
1-128-563-11 ELECT
100uF
20%
C491
1-162-294-31 CERAMIC
0.001uF
10%
C492
1-162-306-11 CERAMIC
0.01uF
20%
CN441
7-685-872-09 SCREW +BVTT 3X8 (S)
< CAPACITOR >
C402
C403
C404
C405
1-162-306-11
1-137-749-11
1-137-749-11
1-127-813-11
CERAMIC
MYLAR
MYLAR
ELECT
C405
1-135-516-11 ELECT
0.01uF
0.1uF
0.1uF
3300uF
20%
20%
3300uF
20%
C406
1-127-813-11 ELECT
3300uF
20%
C406
1-135-516-11 ELECT
3300uF
20%
C407
1-162-306-11 CERAMIC
0.01uF
20%
C408
1-162-306-11 CERAMIC
0.01uF
20%
C409
1-127-811-11 ELECT
3300uF
20%
16V
100V
100V
71V
(RG441)
63V
(RG333)
71V
(RG441)
63V
(RG333)
16V
(RG333)
16V
(RG333)
50V
(RG441)
C410
1-127-811-11 ELECT
3300uF
20%
C413
1-136-497-81 FILM
0.1uF
5%
C414
1-136-497-81 FILM
0.1uF
5%
C441
C442
1-126-964-11 ELECT
1-126-964-11 ELECT
10uF
10uF
20%
20%
C443
C444
C445
C446
C447
1-162-294-31
1-162-294-31
1-162-282-31
1-162-282-31
1-126-965-11
0.001uF
0.001uF
100PF
100PF
22uF
10%
10%
10%
10%
20%
50V
50V
50V
50V
50V
(RG333)
C447
1-126-967-11 ELECT
47uF
20%
C448
1-126-965-11 ELECT
22uF
20%
C448
1-126-967-11 ELECT
47uF
20%
C451
1-136-497-81 FILM
0.1uF
5%
50V
(RG441)
50V
(RG333)
50V
(RG441)
50V
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
50V
50V
50V
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
100V
(RG441)
100V
(RG441)
6.3V
(RG441)
10V
50V
50V
50V
(RG333)
100V
(RG333)
50V
(RG333)
16V
(RG441)
< CONNECTOR >
1-778-981-21 CONNECTOR, BOARD TO BOARD 13P
< DIODE >
D401
D402
D441
D442
D443
6-500-360-01
6-500-360-01
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
D10XB20
D10XB20 (RG441)
1SS133T-77
1SS133T-77
1SS133T-77
D444
D445
D446
D481
8-719-991-33
8-719-947-65
8-719-947-65
8-719-991-33
DIODE
DIODE
DIODE
DIODE
1SS133T-77 (RG441)
MTZJ-T-72-16B (RG441)
MTZJ-T-72-16B (RG441)
1SS133T-77
59
HCD-RG333/RG441
AMP
Ref. No.
D482
D483
Part No.
Description
Remark
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77 (RG333)
Ref. No.
Part No.
Description
Remark
R444
1-247-871-91 CARBON
47K
5%
R444
1-247-873-91 CARBON
56K
5%
R445
R446
R447
1-247-831-91 CARBON
1-247-831-91 CARBON
1-247-871-91 CARBON
1K
1K
47K
5%
5%
5%
R447
1-247-873-91 CARBON
56K
5%
R448
1-247-871-91 CARBON
47K
5%
R448
1-247-873-91 CARBON
56K
5%
0 R449
1-217-156-00 METAL
0.22
10%
0 R450
1-217-156-00 METAL
0.22
10%
0 R451
1-217-156-00 METAL
0.22
10%
0 R452
1-217-156-00 METAL
0.22
10%
R453
R454
R455
1-260-076-11 CARBON
1-260-076-11 CARBON
1-247-831-91 CARBON
10
10
1K
5%
5%
5%
R456
R457
1-247-831-91 CARBON
1-249-431-11 CARBON
1K
15K
5%
5%
R457
1-247-863-91 CARBON
22K
5%
R458
1-249-431-11 CARBON
15K
5%
R458
1-247-863-91 CARBON
22K
5%
R459
1-247-871-91 CARBON
47K
5%
R459
1-247-879-91 CARBON
100K
5%
R460
1-247-871-91 CARBON
47K
5%
R460
1-247-879-91 CARBON
100K
5%
R461
1-260-076-11 CARBON
10
5%
R462
R463
1-260-076-11 CARBON
1-260-076-11 CARBON
10
10
5%
5%
R464
1-260-076-11 CARBON
10
5%
R465
R466
1-247-871-91 CARBON
1-247-873-91 CARBON
47K
56K
5%
5%
1-215-872-11 METAL OXIDE
3.3K
5%
1-249-435-11 CARBON
33K
5%
1-215-872-11 METAL OXIDE
3.3K
5%
R469
1-249-435-11 CARBON
33K
5%
R470
1-249-435-11 CARBON
33K
5%
R471
1-249-439-11 CARBON
68K
5%
< GROUND TERMINAL BOARD >
EP401
EP402
EP491
1-537-771-21 TERMINAL BOARD, GROUND
1-537-771-21 TERMINAL BOARD, GROUND
1-537-771-21 TERMINAL BOARD, GROUND (RG441)
< IC >
IC441
IC441
6-600-169-01 IC STK412-240 (RG441)
6-600-221-01 IC STK403-130 (RG333)
< TERMINAL BOARD >
JK441
1-694-884-11 TERMINAL BOARD (4P) (SPEAKER)
< COIL >
L441
L441
L442
L442
1-422-009-13
1-422-009-13
1-422-009-13
1-422-009-13
COIL, AIR-CORE (RG441)
COIL, AIR-CORE (RG333)
COIL, AIR-CORE (RG441)
COIL, AIR-CORE (RG333)
< TRANSISTOR >
Q441
Q442
Q481
Q482
Q483
8-729-140-84
8-729-140-84
8-729-119-79
8-729-119-79
8-729-119-79
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1841-PAFAEA
2SC1841-PAFAEA
2SC2785-FEK
2SC2785-FEK
2SC2785-FEK
Q484
Q485
Q486
Q487
Q488
8-729-119-79
8-729-119-76
8-729-119-79
8-729-119-79
8-729-119-79
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-FEK
2SA1175-HFE
2SC2785-FEK
2SC2785-FEK
2SC2785-FEK
Q489
Q490
Q491
8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
8-729-140-84 TRANSISTOR 2SC1841-PAFAEA (RG441)
8-729-821-00 TRANSISTOR 2SA1207 (RG441)
< RESISTOR >
R401
R402
R403
1-247-879-91 CARBON
1-247-879-91 CARBON
1-247-879-91 CARBON
100K
100K
100K
5%
5%
5%
R404
1-247-879-91 CARBON
100K
5%
R407
1-260-316-51 CARBON
100
5%
R409
1-247-879-91 CARBON
100K
5%
R410
1-247-879-91 CARBON
100K
5%
R411
R412
R413
1-249-421-11 CARBON
1-249-421-11 CARBON
1-247-847-91 CARBON
2.2K
2.2K
4.7K
5%
5%
5%
R414
R441
R442
R443
1-247-847-91
1-247-831-91
1-247-831-91
1-247-871-91
CARBON
CARBON
CARBON
CARBON
4.7K
1K
1K
47K
5%
5%
5%
5%
R443
1-247-873-91 CARBON
56K
5%
1/4W
1/4W
1/4W
(RG441)
1/4W
(RG441)
1/2W
1/4W
(RG441)
1/4W
(RG441)
1/4W
1/4W
1/4W
0 R467
R467
0 R468
60
1/4W
1/4W
1/4W
1/4W
(RG333)
1/4W
(RG441)
1/4W
(RG333)
1/4W
(RG441)
1/4W
1/4W
1/4W
(RG333)
1/4W
(RG441)
1/4W
(RG333)
1/4W
(RG441)
5W
F
(RG441)
5W
F
(RG441)
5W
F
(RG333)
5W
F
(RG333)
1/2W
1/2W
1/4W
1/4W
1/4W
(RG441)
1/4W
(RG333)
1/4W
(RG441)
1/4W
(RG333)
1/4W
(RG333)
1/4W
(RG441)
1/4W
(RG333)
1/4W
(RG441)
1/2W
1/2W
1/2W
(RG333)
1/2W
(RG333)
1/4W
1/4W
1W
F
(RG441)
1/4W
(RG333)
1W
F
(RG441)
1/4W
(RG441)
1/4W
(RG441)
1/4W
(RG441)
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
HCD-RG333/RG441
AMP
Ref. No.
Part No.
Description
Remark
R472
1-249-435-11 CARBON
33K
5%
R473
1-247-863-91 CARBON
22K
5%
R474
1-249-421-11 CARBON
2.2K
5%
R475
1-249-429-11 CARBON
10K
5%
R476
1-249-431-11 CARBON
15K
5%
1/4W
(RG441)
1/4W
(RG441)
1/4W
(RG441)
1/4W
(RG441)
1/4W
(RG441)
0 R477
1-212-881-11 FUSIBLE
100
5%
R478
1-249-429-11 CARBON
10K
5%
R481
R482
R483
1-247-847-91 CARBON
1-249-429-11 CARBON
1-247-791-91 CARBON
4.7K
10K
22
5%
5%
5%
1/4W F
(RG441)
1/4W
(RG441)
1/4W
1/4W
1/4W
R484
R485
R486
R487
R488
1-247-873-91
1-247-879-91
1-247-879-91
1-249-435-11
1-247-863-91
CARBON
CARBON
CARBON
CARBON
CARBON
56K
100K
100K
33K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R489
R490
R491
1-247-847-91 CARBON
1-247-847-91 CARBON
1-247-863-91 CARBON
4.7K
4.7K
22K
5%
5%
5%
R492
1-247-831-91 CARBON
1K
5%
R493
1-249-435-11 CARBON
33K
5%
1/4W
1/4W
1/4W
(RG333)
1/4W
(RG333)
1/4W
(RG333)
R494
1-249-421-11 CARBON
2.2K
5%
0 R495
0 R496
1-202-972-61 FUSIBLE
1-212-881-11 FUSIBLE
1
100
5%
5%
1/4W
(RG333)
1/4W F
1/4W F
< RELAY >
RY441
RY441
1-755-372-11 RELAY (RG441)
1-755-373-11 RELAY (RG333)
< THERMISTOR >
TH441 1-807-796-11 THERMISTOR
*************************************************************
A-4751-431-A BD81A BOARD, COMPLETE
**********************
< CAPACITOR >
Ref. No.
BD81A
Part No.
Description
C122
C123
C124
C125
C131
1-107-826-11
1-107-826-11
1-162-959-11
1-164-360-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
330PF
0.1uF
100PF
10%
10%
5%
Remark
C132
C133
C134
C141
C142
1-117-863-11
1-162-970-11
1-164-360-11
1-107-826-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
0.01uF
0.1uF
0.1uF
0.0015uF
10%
10%
C143
C151
C161
C162
C163
1-164-360-11
1-128-995-21
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
0.1uF
0.1uF
0.1uF
C171
C172
C174
C181
C182
1-162-919-11
1-162-920-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
27PF
0.1uF
0.1uF
0.1uF
5%
5%
50V
50V
16V
16V
16V
C183
C184
C185
C186
C194
1-124-778-00
1-124-778-00
1-164-315-11
1-164-315-11
1-164-360-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
22uF
470PF
470PF
0.1uF
20%
20%
5%
5%
6.3V
6.3V
50V
50V
16V
C195
C196
C201
C203
C209
1-164-360-11
1-164-360-11
1-128-995-21
1-128-995-21
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
100uF
100uF
0.01uF
20%
20%
10%
16V
16V
10V
10V
25V
C210
C211
C212
C213
C251
1-107-826-11
1-164-230-11
1-162-919-11
1-162-919-11
1-162-969-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220PF
22PF
22PF
0.0068uF
10%
5%
5%
5%
10%
16V
50V
50V
50V
25V
C252
C255
C257
C258
C259
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
C260
C302
C303
C305
C306
1-128-394-11
1-164-360-11
1-164-360-11
1-126-246-11
1-164-360-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
220uF
0.1uF
0.1uF
220uF
0.1uF
5%
10%
10%
20%
16V
16V
50V
16V
50V
6.3V
25V
16V
16V
50V
16V
10V
16V
16V
16V
16V
16V
16V
16V
16V
20%
20%
10V
16V
16V
4V
16V
C10
C11
C14
C15
C16
1-165-989-11
1-165-989-11
1-164-360-11
1-164-360-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.1uF
0.1uF
1uF
10%
10%
6.3V
6.3V
16V
16V
10V
C307
C308
C309
C310
C311
1-164-360-11
1-126-208-21
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.1uF
0.1uF
0.1uF
C17
C18
C111
C112
C113
1-126-246-11
1-162-964-11
1-162-967-11
1-164-315-11
1-162-967-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
0.001uF
0.0033uF
470PF
0.0033uF
20%
10%
10%
5%
10%
4V
50V
50V
50V
50V
C312
C313
C314
C315
C316
1-164-360-11
1-164-360-11
1-126-208-21
1-107-826-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47uF
20%
0.1uF
10%
0.0022uF 10%
16V
16V
4V
16V
50V
C114
C115
C116
1-164-315-11 CERAMIC CHIP
1-164-360-11 CERAMIC CHIP
1-128-995-21 ELECT CHIP
470PF
0.1uF
100uF
5%
50V
16V
10V
C317
C318
C320
1-162-970-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
1-216-864-11 SHORT CHIP
0.01uF
0.01uF
0
25V
25V
20%
20%
10%
10%
16V
4V
16V
16V
16V
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
61
HCD-RG333/RG441
BD81A
Ref. No.
CONNECT
Part No.
DRIVER
Description
Remark
< CONNECTOR >
CN101
CN201
1-770-425-11 CONNECTOR, FFC/FPC 16P
1-818-350-11 CONNECTOR (FFC) 27P
Ref. No.
Part No.
Description
R351
R352
R353
R354
R401
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R402
R403
R404
R405
R406
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R407
R408
R409
R410
R411
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R412
R419
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
< FERRITE BEAD >
FB301
1-500-445-21 FERRITE, EMI (SMD) (2012)
< IC >
IC101
IC251
IC301
IC303
8-752-425-12
6-705-808-01
6-705-365-01
6-705-807-01
IC
IC
IC
IC
CXD3059AR
BA5947FM
TC94A34FG-002
BH15FB1WG
< TRANSISTOR >
Q10
6-550-363-01 TRANSISTOR 2SB1690KT146
< RESISTOR >
< VIBRATOR >
R10
R11
R12
R13
R111
1-216-791-11
1-216-864-11
1-216-845-11
1-218-446-11
1-216-821-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
0
100K
1
1K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R112
R113
R114
R121
R131
1-216-835-11
1-216-821-11
1-216-835-11
1-216-835-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
1K
15K
15K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R132
R133
R141
R142
R143
1-216-833-11
1-216-848-11
1-216-829-11
1-216-821-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
180K
4.7K
1K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R151
R161
R162
R163
R165
1-216-864-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-864-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
100
47K
100
0
R171
R172
R173
R181
R182
1-216-817-11
1-216-857-11
1-216-295-91
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
470
1M
0
100
100
R191
R201
R203
R204
R205
1-216-864-11
1-500-445-21
1-216-864-11
1-500-445-21
1-216-864-11
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
R251
R252
R253
R301
R302
1-216-833-11
1-216-837-11
1-216-833-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C715
C731
C735
C736
C737
1-126-933-11
1-126-964-11
1-164-159-21
1-164-159-21
1-164-159-21
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
100uF
10uF
0.1uF
0.1uF
0.1uF
20%
20%
16V
50V
50V
50V
50V
R303
R305
R306
R307
R313
1-216-845-11
1-216-845-11
1-216-864-11
1-216-833-11
1-216-813-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
100K
0
10K
220
5%
5%
1/10W
1/10W
C741
C751
C752
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-164-159-21 CERAMIC
0.01uF
0.01uF
0.1uF
20%
20%
16V
16V
50V
5%
5%
1/10W
1/10W
X171
1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz)
*************************************************************
CONNECT BOARD
***************
< CAPACITOR >
C871
C872
C873
C874
C875
1-162-927-11
1-162-970-11
1-162-927-11
1-164-315-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C876
1-164-156-11 CERAMIC CHIP
100PF
0.01uF
100PF
470PF
0.1uF
5%
10%
5%
5%
0.1uF
50V
25V
50V
50V
25V
25V
< CONNECTOR >
5%
5%
5%
1/10W
1/10W
1/10W
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
CN871
CN873
* CN874
1-779-295-11 CONNECTOR, FFC (LIF(NON-ZIF)) 27P
1-784-778-11 CONNECTOR, FFC 17P
1-564-725-11 PIN, CONNECTOR (SMALL TYPE) 9P
< JUMPER RESISTOR >
62
FB871 1-216-864-11 SHORT CHIP
0
FB872 1-216-864-11 SHORT CHIP
0
JR871 1-216-864-11 SHORT CHIP
0
JR872 1-216-864-11 SHORT CHIP
0
*************************************************************
1-687-135-12 DRIVER BOARD
*************
< CAPACITOR >
HCD-RG333/RG441
DRIVER
Ref. No.
Part No.
Description
GAME JACK
Remark
Ref. No.
H/P JACK
Part No.
1-785-338-11
1-784-766-11
1-564-720-11
1-785-328-11
PIN, CONNECTOR (LIGHT ANGLE) 12P
CONNECTOR, FFC 5P
PIN, CONNECTOR (SMALL TYPE) 4P
PIN, CONNECTOR (LIGHT ANGLE) 2P
C830
C831
C832
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.001uF
0.001uF
0.1uF
10%
10%
50V
50V
25V
J801
1-793-829-11 JACK, HEADPHONE (PHONES)
*************************************************************
LEAD BOARD (RG333)
***********
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
< CAPACITOR >
< TRANSISTOR >
Q731
Remark
< JACK >
8-719-921-42 DIODE MTZJ-5.1A
8-719-109-69 DIODE RD3.6ESB2
< IC >
IC701
IC712
Description
< CAPACITOR >
< DIODE >
D701
D711
MAIN
H/P JACK BOARD
**************
< CONNECTOR >
CN701
CN702
* CN703
CN704
LEAD
C861
8-729-029-66 TRANSISTOR DTC114ESA
1-162-964-11 CERAMIC CHIP
0.001uF
10%
50V
(RG333)
< RESISTOR >
< GROUND TERMINAL BOARD >
R701
R702
R711
R712
R713
1-249-413-11
1-247-807-31
1-249-417-11
1-249-425-11
1-249-433-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
100
1K
4.7K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R721
R722
R723
R731
R732
1-249-425-11
1-249-425-11
1-249-425-11
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
4.7K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
EP802 1-537-771-21 TERMINAL BOARD, GROUND (RG333)
*************************************************************
A-4751-788-A MAIN BOARD, COMPLETE (RG333)
A-4752-183-A MAIN BOARD, COMPLETE (RG441)
*********************
7-685-872-09 SCREW +BVTT 3X8 (S)
< CAPACITOR >
R733
1-249-417-11 CARBON
1K
5%
1/4W
R734
1-249-430-11 CARBON
12K
5%
1/4W
R735
1-247-807-31 CARBON
100
5%
1/4W
R751
1-249-425-11 CARBON
4.7K
5%
1/4W
*************************************************************
C101
C102
C103
C104
C105
1-126-960-11
1-126-960-11
1-126-956-91
1-126-956-91
1-164-816-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
0.1uF
0.1uF
220PF
20%
20%
20%
20%
2%
50V
50V
50V
50V
50V
GAME JACK BOARD
****************
C106
C107
C108
C109
C110
1-131-679-31
1-126-964-11
1-164-816-11
1-131-679-31
1-126-964-11
FILM
ELECT
CERAMIC CHIP
FILM
ELECT
0.01uF
10uF
220PF
0.01uF
10uF
5%
20%
2%
5%
20%
50V
50V
50V
50V
50V
C111
C112
C113
C114
C115
1-126-960-11
1-126-960-11
1-126-960-11
1-126-960-11
1-131-679-31
ELECT
ELECT
ELECT
ELECT
FILM
1uF
1uF
1uF
1uF
0.01uF
20%
20%
20%
20%
5%
50V
50V
50V
50V
50V
C116
C117
C118
C119
C120
1-164-816-11
1-164-816-11
1-126-964-11
1-131-679-31
1-164-816-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
FILM
CERAMIC CHIP
220PF
220PF
10uF
0.01uF
220PF
2%
2%
20%
5%
2%
50V
50V
50V
50V
50V
C121
C122
C123
C124
C125
1-164-816-11
1-126-964-11
1-126-965-91
1-162-953-11
1-162-953-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
220PF
10uF
22uF
100PF
100PF
2%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C126
C127
C128
C129
1-165-112-11
1-104-658-91
1-104-658-91
1-126-947-11
CERAMIC CHIP
ELECT
ELECT
ELECT
0.33uF
100uF
100uF
47uF
20%
20%
20%
16V
10V
10V
35V
< CAPACITOR >
C801
C802
C803
C804
1-162-962-11
1-162-962-11
1-165-128-11
1-165-128-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
470PF
0.22uF
0.22uF
10%
10%
50V
50V
16V
16V
< JACK >
J804
1-815-684-11 JACK, PIN 3P (GAME INPUT)
< JUMPER RESISTOR >
JR801
1-216-864-11 SHORT CHIP
0
< RESISTOR >
R801
1-216-833-11 METAL CHIP
10K
5%
1/10W
R802
1-216-833-11 METAL CHIP
10K
5%
1/10W
R803
1-216-837-11 METAL CHIP
22K
5%
1/10W
R804
1-216-837-11 METAL CHIP
22K
5%
1/10W
*************************************************************
63
HCD-RG333/RG441
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C132
C135
C136
C137
C138
1-126-947-11
1-131-690-31
1-131-690-31
1-126-964-11
1-126-964-11
ELECT
FILM
FILM
ELECT
ELECT
47uF
0.068uF
0.068uF
10uF
10uF
20%
5%
5%
20%
20%
35V
50V
50V
50V
50V
Remark
C229
C230
C235
C241
C242
1-126-963-11
1-126-947-11
1-164-156-11
1-162-964-11
1-130-479-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
MYLAR
4.7uF
47uF
0.1uF
0.001uF
0.0047uF
20%
20%
10%
5%
50V
35V
25V
50V
50V
C139
C140
C141
C142
C143
1-131-690-31
1-131-690-31
1-126-964-11
1-126-964-11
1-126-960-11
FILM
FILM
ELECT
ELECT
ELECT
0.068uF
0.068uF
10uF
10uF
1uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C243
C244
C246
C248
C249
1-131-681-31
1-131-681-31
1-131-681-31
1-162-964-11
1-126-964-11
FILM
FILM
FILM
CERAMIC CHIP
ELECT
0.015uF
0.015uF
0.015uF
0.001uF
10uF
5%
5%
5%
10%
20%
50V
50V
50V
50V
50V
C144
C145
C146
C147
C148
1-136-165-00
1-126-964-11
1-136-165-00
1-126-964-11
1-131-679-31
FILM
ELECT
FILM
ELECT
FILM
0.1uF
10uF
0.1uF
10uF
0.01uF
5%
20%
5%
20%
5%
50V
50V
50V
50V
50V
C250
C251
C252
C253
C258
1-126-947-11
1-126-947-11
1-126-933-11
1-126-956-91
1-126-959-11
ELECT
ELECT
ELECT
ELECT
ELECT
47uF
47uF
100uF
0.1uF
0.47uF
20%
20%
20%
20%
20%
35V
35V
16V
50V
50V
C149
C150
C151
C152
C153
1-131-679-31
1-131-679-31
1-131-679-31
1-130-475-00
1-130-475-00
FILM
FILM
FILM
MYLAR
MYLAR
0.01uF
0.01uF
0.01uF
0.0022uF
0.0022uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C259
C264
C265
C266
C267
1-126-957-11
1-162-971-11
1-162-971-11
1-162-971-11
1-162-971-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.001uF
0.001uF
0.001uF
0.001uF
20%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C154
C157
C159
C160
C161
1-131-700-31
1-126-960-11
1-126-960-11
1-126-960-11
1-162-971-11
FILM
ELECT
ELECT
ELECT
CERAMIC CHIP
0.47uF
1uF
1uF
1uF
0.001uF
5%
20%
20%
20%
10%
50V
50V
50V
50V
50V
(RG333)
C270
C271
1-126-964-11 ELECT
1-162-971-11 CERAMIC CHIP
10uF
0.001uF
20%
10%
C272
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C274
C275
1-162-949-11 CERAMIC CHIP
1-162-949-11 CERAMIC CHIP
47PF
47PF
5%
5%
50V
50V
(RG333)
50V
(RG333)
50V
50V
C276
1-164-362-11 CERAMIC CHIP
470PF
5%
C277
1-164-362-11 CERAMIC CHIP
470PF
5%
C278
1-164-362-11 CERAMIC CHIP
470PF
5%
C279
1-164-362-11 CERAMIC CHIP
470PF
5%
C280
1-164-362-11 CERAMIC CHIP
470PF
5%
C281
1-164-362-11 CERAMIC CHIP
470PF
5%
C288
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C289
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C290
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C301
1-136-165-00 FILM
0.1uF
5%
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
C302
C303
C304
C305
C306
1-136-165-00
1-136-165-00
1-136-165-00
1-136-165-00
1-136-165-00
FILM
FILM
FILM
FILM
FILM
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C308
C309
C310
C311
C312
1-126-965-91
1-126-965-91
1-126-936-11
1-126-964-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
22uF
22uF
3300uF
10uF
10uF
20%
20%
20%
20%
20%
50V
50V
16V
50V
50V
C313
C315
C316
C318
1-126-943-11
1-126-933-11
1-126-943-11
1-126-933-11
ELECT
ELECT
ELECT
ELECT
2200uF
100uF
2200uF
100uF
20%
20%
20%
20%
25V
16V
25V
16V
C162
C163
1-126-960-11 ELECT
1-162-971-11 CERAMIC CHIP
1uF
0.001uF
20%
10%
C164
C165
C166
1-126-960-11 ELECT
1-126-960-11 ELECT
1-126-960-11 ELECT
1uF
1uF
1uF
20%
20%
20%
50V
50V
(RG333)
50V
50V
50V
C175
C176
C177
C178
C179
1-109-953-11
1-126-964-11
1-162-945-11
1-126-947-11
1-162-949-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
2.2uF
10uF
22PF
47uF
47PF
20%
20%
5%
20%
5%
50V
50V
50V
35V
50V
C181
C183
C184
C185
C186
1-162-949-11
1-162-945-11
1-126-947-11
1-126-964-11
1-126-947-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
47PF
22PF
47uF
10uF
47uF
5%
5%
20%
20%
20%
50V
50V
35V
50V
35V
C187
C188
C189
C190
C191
1-162-974-11
1-126-965-91
1-126-965-91
1-162-974-11
1-126-961-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
0.01uF
22uF
22uF
0.01uF
2.2uF
C192
C193
C206
C211
C212
1-126-961-11
1-162-966-11
1-162-966-11
1-109-953-11
1-126-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
C213
C214
C216
C217
C222
1-126-964-11
1-126-926-11
1-164-156-11
1-164-156-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C228
1-164-156-11 CERAMIC CHIP
64
20%
50V
50V
50V
50V
50V
2.2uF
0.0022uF
0.0022uF
2.2uF
10uF
20%
10%
10%
20%
20%
50V
50V
50V
50V
50V
10uF
1000uF
0.1uF
0.1uF
0.1uF
20%
20%
50V
10V
25V
25V
25V
0.1uF
20%
20%
25V
Ref. No.
Remark
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
50V
(RG333)
HCD-RG333/RG441
MAIN
Ref. No.
Part No.
Description
C321
C342
C351
C352
C353
1-126-961-11
1-164-156-11
1-164-357-11
1-126-965-91
1-126-961-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
2.2uF
0.1uF
0.001uF
22uF
2.2uF
Remark
C354
C371
C372
C373
C374
1-164-156-11
1-164-362-11
1-162-953-11
1-162-953-11
1-126-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
C375
C376
1-164-156-11 CERAMIC CHIP
1-126-961-11 ELECT
20%
5%
20%
20%
50V
25V
50V
50V
50V
0.1uF
470PF
100PF
100PF
47uF
5%
5%
5%
20%
25V
50V
50V
50V
35V
0.1uF
2.2uF
20%
25V
50V
< CONNECTOR >
CN101
CN101
* CN103
* CN112
CN302
1-568-830-11
1-784-776-11
1-564-710-11
1-564-705-11
1-568-844-11
CONNECTOR, FFC 11P (RG441)
CONNECTOR, FFC 15P (RG333)
PIN, CONNECTOR (SMALL TYPE) 8P
PIN, CONNECTOR (SMALL TYPE) 3P
CONNECTOR, FFC 29P (RG441)
CN302
CN307
CN308
CN309
CN314
1-784-792-11
1-778-982-21
1-564-506-11
1-564-707-11
1-564-506-11
CONNECTOR, FFC 31P (RG333)
CONNECTOR, BOARD TO BOARD 13P
PLUG, CONNECTOR 3P
PIN, CONNECTOR (SMALL TYPE) 5P
PLUG, CONNECTOR 3P
Ref. No.
Part No.
Description
Remark
< JUMPER RESISTOR >
FB201
FB202
FB203
FB204
FB205
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0 (RG441)
FB205
1-543-958-22 BEAD, FERRITE (CHIP) (1608) (RG333)
< IC >
IC101
IC102
IC201
IC301
IC302
6-705-852-01
8-759-710-97
8-759-508-69
6-702-771-01
6-702-771-01
IC
IC
IC
IC
IC
BD3401KS2
NJM4565M-D
BA3126N
TA78033LS
TA78033LS
IC303
IC304
IC371
8-759-701-59 IC NJM78M09FA
8-759-701-59 IC NJM78M09FA
6-704-046-01 IC BU2099FV
< COIL >
< DIODE >
D201
D202
D206
D207
D211
8-719-988-61
8-719-083-63
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
UDZSTE-1713B
1SS355TE-17
1SS355TE-17
1SS355TE-17
D212
D213
D214
D215
D301
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
10EDB40-TB3
D302
D303
D304
D305
D306
6-500-522-21
6-500-522-21
6-500-522-21
6-500-522-21
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
D307
D308
D309
D310
D311
6-500-522-21
6-500-522-21
6-500-522-21
6-500-522-21
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
D312
D313
D316
D321
D322
6-500-522-21
8-719-085-36
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
10EDB40-TB3
11EQS04-TB5
1SS355TE-17
1SS355TE-17
1SS355TE-17
D324
D325
D326
6-500-522-21 DIODE 10EDB40-TB3
6-500-522-21 DIODE 10EDB40-TB3
6-500-522-21 DIODE 10EDB40-TB3
< GROUND TERMINAL BOARD >
EP101
EP301
1-537-771-21 TERMINAL BOARD, GROUND
1-537-771-21 TERMINAL BOARD, GROUND
L101
1-424-849-11 COIL, OSCILLATION (BIAS)
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-120-28
6-550-580-01
6-550-889-01
6-550-889-01
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SA1235TP-1F
2SC5938-T112-1B
2SC5938-T112-1B
2SC1623-L5L6
Q106
Q107
Q304
Q305
Q306
8-729-120-28
8-729-120-28
8-729-120-28
6-550-580-01
6-550-889-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SA1235TP-1F
2SC5938-T112-1B
Q307
Q308
Q309
Q310
Q311
6-550-889-01
6-550-580-01
8-729-120-28
8-729-142-46
8-729-142-46
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC5938-T112-1B
2SA1235TP-1F
2SC1623-L5L6
2SC2001-LK
2SC2001-LK
Q312
Q313
Q314
Q315
Q321
8-729-041-19
8-729-120-28
6-550-580-01
8-729-120-28
8-729-142-46
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA953-T-K
2SC1623-L5L6
2SA1235TP-1F
2SC1623-L5L6
2SC2001-LK
Q322
Q323
Q324
Q327
Q351
6-550-580-01
8-729-120-28
8-729-140-04
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1235TP-1F
2SC1623-L5L6
2SB1116A-L
2SC1623-L5L6
2SC1623-L5L6
Q352
Q361
Q362
8-729-120-28 TRANSISTOR 2SC1623-L5L6
6-550-580-01 TRANSISTOR 2SA1235TP-1F
8-729-120-28 TRANSISTOR 2SC1623-L5L6
< RESISTOR >
R101
R102
R103
R104
R105
1-216-833-11
1-216-833-11
1-216-851-11
1-216-835-11
1-216-816-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
330K
15K
390
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
65
HCD-RG333/RG441
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R106
R107
R108
R109
R110
1-216-851-11
1-216-835-11
1-216-816-11
1-216-853-11
1-216-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330K
15K
390
470K
330K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R197
R198
R201
R202
R203
1-216-825-11
1-216-825-11
1-216-829-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
4.7K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R111
R112
R113
R114
R115
1-216-847-11
1-216-853-11
1-216-851-11
1-216-847-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150K
470K
330K
150K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R204
R205
R206
R207
R208
1-216-833-11
1-216-829-11
1-216-841-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
47K
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R117
R119
R120
R121
1-216-809-11
1-216-809-11
1-216-841-11
1-216-857-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
47K
1M
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R209
R210
R211
R212
R213
1-216-833-11
1-216-825-11
1-216-821-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
1K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R127
R128
R129
R131
R132
1-216-829-11
1-216-835-11
1-216-841-11
1-216-835-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
15K
47K
15K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R214
R216
R217
0 R218
1-216-821-11
1-216-806-11
1-216-806-11
1-215-891-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL OXIDE
1K
56
56
680
5%
5%
5%
5%
0 R218
1-215-916-00 METAL OXIDE
680
5%
R133
R134
R135
R136
R137
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
2W
F
(RG333)
3W
F
(RG441)
0 R219
1-215-891-11 METAL OXIDE
680
5%
0 R219
1-215-916-00 METAL OXIDE
680
5%
R138
R139
R141
R142
R151
1-216-821-11
1-216-864-11
1-216-821-11
1-216-821-11
1-216-829-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
1K
1K
4.7K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R220
R221
R222
1-216-837-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-830-11 METAL CHIP
22K
22K
5.6K
5%
5%
5%
2W
F
(RG333)
3W
F
(RG441)
1/10W
1/10W
1/10W
R152
R153
R154
R155
R156
1-216-833-11
1-216-833-11
1-216-833-11
1-216-829-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
4.7K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R223
R225
R226
R227
R228
1-216-864-11
1-216-829-11
1-216-841-11
1-216-821-11
1-216-821-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
4.7K
47K
1K
1K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R157
R158
R159
R160
R161
1-216-841-11
1-216-825-11
1-216-833-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
2.2K
10K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R229
R230
R231
R232
R241
1-216-829-11
1-216-829-11
1-216-825-11
1-216-833-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
2.2K
10K
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R162
R163
R164
R165
R166
1-216-825-11
1-216-833-11
1-216-821-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
1K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R242
R243
R244
R245
R246
1-216-838-11
1-216-832-11
1-216-832-11
1-216-829-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
8.2K
8.2K
4.7K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R167
R168
R169
R170
R171
1-216-833-11
1-216-845-11
1-216-845-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
100K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R247
R248
R249
R250
R251
1-216-833-11
1-216-833-11
1-216-841-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
47K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R172
R173
R174
R175
R176
1-216-809-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
10K
10K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R252
R253
R254
R262
R263
1-216-864-11
1-216-809-11
1-216-809-11
1-216-827-11
1-216-857-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
3.3K
1M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R177
R194
R195
1-216-849-11 METAL CHIP
1-218-867-11 METAL CHIP
1-218-867-11 METAL CHIP
220K
6.8K
6.8K
5%
0.5%
0.5%
1/10W
1/10W
1/10W
R264
R265
R266
R272
R273
1-216-821-11
1-216-833-11
1-216-845-11
1-216-853-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
1K
10K
100K
470K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
66
Remark
Ref. No.
Remark
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
HCD-RG333/RG441
MAIN
Ref. No.
Part No.
Description
R274
R275
R281
R282
R283
1-216-864-11
1-216-864-11
1-216-825-11
1-216-825-11
1-216-825-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
2.2K
2.2K
2.2K
R284
R306
R307
R308
R310
1-216-825-11
1-216-833-11
1-216-833-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R311
R312
R313
R321
R322
1-216-829-11
1-216-837-11
1-216-829-11
1-216-829-11
1-216-837-11
R323
R324
R325
R341
R342
MOTOR (LD)
Part No.
MOTOR (TB)
PANEL
Remark
Ref. No.
5%
5%
5%
1/10W
1/10W
1/10W
R392
1-216-821-11 METAL CHIP
1K
5%
1/10W
R393
1-216-833-11 METAL CHIP
10K
5%
1/10W
R394
1-216-821-11 METAL CHIP
1K
5%
1/10W
R395
1-216-837-11 METAL CHIP
22K
5%
1/10W
*************************************************************
Description
Remark
2.2K
10K
10K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
22K
4.7K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-829-11
1-216-833-11
1-216-829-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
4.7K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R343
R344
R345
R346
R347
1-216-837-11
1-216-837-11
1-216-833-11
1-216-821-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
10K
1K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C601
C602
C603
C604
C605
1-162-919-11
1-162-919-11
1-162-919-11
1-164-156-11
1-126-163-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
22PF
22PF
22PF
0.1uF
4.7uF
R348
R351
R352
R353
R354
1-216-837-11
1-216-835-11
1-216-845-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
15K
100K
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C606
C607
C608
C609
C610
1-115-156-11
1-162-964-11
1-162-970-11
1-115-156-11
1-126-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.001uF
0.01uF
1uF
1000uF
R356
R357
R358
R361
R362
1-216-817-11
1-216-825-11
1-216-809-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
2.2K
100
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C611
C612
C613
C614
C615
1-164-156-11
1-126-157-11
1-164-156-11
1-164-156-11
1-124-257-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
10uF
0.1uF
0.1uF
2.2uF
R363
R364
R371
R372
R373
1-216-829-11
1-216-829-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C617
C618
C619
C620
C621
1-162-964-11
1-162-964-11
1-124-589-11
1-119-772-91
1-162-995-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.001uF
0.001uF
47uF
47uF
0.022uF
10%
10%
20%
20%
50V
50V
16V
35V
50V
R374
R375
R376
R377
R378
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C622
C623
C624
C625
C626
1-126-163-11
1-126-163-11
1-162-918-11
1-162-919-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
18PF
22PF
0.1uF
20%
20%
5%
5%
50V
50V
50V
50V
25V
R379
R380
R381
R382
R383
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C628
C629
C630
C631
C632
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
R384
R385
R386
R387
R388
1-216-833-11
1-216-829-11
1-216-837-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
22K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C633
C634
C635
C636
C637
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
R389
R390
R391
1-216-829-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-833-11 METAL CHIP
4.7K
22K
10K
5%
5%
5%
1/10W
1/10W
1/10W
C638
C639
C640
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
100PF
100PF
100PF
5%
5%
5%
50V
50V
50V
1-687-133-12 MOTOR (LD) BOARD
*****************
*************************************************************
1-687-134-12 MOTOR (TB) BOARD
*****************
< CONNECTOR >
CN742 1-784-727-11 CONNECTOR, FFC 5P
*************************************************************
A-4751-547-A PANEL BOARD, COMPLETE (RG333)
A-4751-553-A PANEL BOARD, COMPLETE (RG441)
**********************
< CAPACITOR >
5%
5%
5%
20%
10%
10%
20%
20%
20%
50V
50V
50V
25V
50V
10V
50V
25V
10V
6.3V
25V
16V
25V
25V
50V
67
HCD-RG333/RG441
PANEL
Ref. No.
Part No.
Description
C641
C642
C643
C644
C646
1-164-156-11
1-164-156-11
1-164-156-11
1-126-157-11
1-124-234-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
0.1uF
10uF
22uF
Remark
C647
C648
C649
C653
C654
1-124-589-11
1-124-234-00
1-164-156-11
1-162-959-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
22uF
0.1uF
330PF
0.1uF
C655
C656
1-164-156-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
0.1uF
100PF
20%
20%
20%
20%
5%
5%
25V
25V
25V
16V
16V
16V
16V
25V
50V
25V
25V
50V
Ref. No.
Part No.
Description
Remark
< JUMPER RESISTOR >
JR607
JR608
JR609
JR611
JR612
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0 (RG441)
0 (RG441)
JR614
JR617
JR621
JR622
JR623
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< DIODE >
< CONNECTOR >
LED601 6-500-809-01 LED SELU5223C-STP15 (?/1)
CN601
CN601
CN602
CN603
* CN604
CN605
CN608
1-784-751-11
1-784-753-11
1-784-774-11
1-784-778-11
1-564-708-11
CONNECTOR, FFC 29P (RG441)
CONNECTOR, FFC 31P (RG333)
CONNECTOR, FFC 13P
CONNECTOR, FFC 17P
PIN, CONNECTOR (SMALL TYPE) 6P
1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
1-818-282-11 PIN, CONNECTOR 3P
< DIODE >
D603
D604
D605
* D606
D607
8-719-988-61
8-719-988-61
8-719-988-61
6-500-486-01
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
PTZ-TE25-11B (RG441)
1SS355TE-17
D608
D609
D610
D611
D613
8-719-988-61
8-719-988-61
8-719-056-78
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
UDZ-TE-17-4.3B
1SS355TE-17
1SS355TE-17
D614
D615
D616
D620
D621
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D622
D623
D625
D626
D630
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17 (RG333)
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D631
D632
D633
8-719-978-33 DIODE DTZ-TT11-6.8B
8-719-083-57 DIODE UDZSTE-173.6B
8-719-988-61 DIODE 1SS355TE-17
< FLUORESCENT INDICATOR >
FL601
1-518-976-11 INDICATOR TUBE, FLUORESCENT
< TRANSISTOR >
Q601
Q602
Q603
Q604
Q605
8-729-116-57
8-729-140-04
8-729-140-04
8-729-119-76
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1068-K
2SB1116A-L
2SB1116A-L
2SA1175-HFE
2SC1623-L5L6
Q610
Q611
Q612
Q613
Q614
8-729-027-55
8-729-027-55
8-729-027-55
8-729-027-55
8-729-027-55
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC143EKA-T146
DTC143EKA-T146
DTC143EKA-T146
DTC143EKA-T146
DTC143EKA-T146
Q615
Q616
8-729-027-55 TRANSISTOR DTC143EKA-T146
8-729-027-55 TRANSISTOR DTC143EKA-T146
< RESISTOR >
R601
R602
R603
R604
R605
1-216-829-11
1-216-829-11
1-216-829-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R606
R607
R608
R609
R610
1-216-829-11
1-216-841-11
1-216-829-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
4.7K
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R611
R612
R613
R614
R615
1-216-837-11
1-216-833-11
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R616
R617
R618
R619
R620
1-216-833-11
1-216-837-11
1-216-833-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R621
R622
R623
R624
R625
1-216-833-11
1-216-049-11
1-216-833-11
1-216-049-11
1-216-833-11
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
1K
10K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R626
R627
1-216-049-11 RES-CHIP
1-216-833-11 METAL CHIP
1K
10K
5%
5%
1/10W
1/10W
< IC >
IC601
IC602
IC603
IC604
68
6-804-440-01
6-704-046-01
6-704-045-01
8-759-533-04
IC
IC
IC
IC
LC876996A-53H2-E
BU2099FV
MM1574ANLE
M62703ML-E1
HCD-RG333/RG441
PANEL
Ref. No.
Part No.
Description
Remark
R628
R629
R630
1-216-833-11 METAL CHIP
1-216-150-91 RES-CHIP
1-216-809-11 METAL CHIP
10K
10
100
5%
5%
5%
R631
1-216-809-11 METAL CHIP
100
5%
R632
1-216-809-11 METAL CHIP
100
5%
1/10W
1/8W
1/10W
(RG333)
1/10W
(RG333)
1/10W
R633
R634
R635
R636
R637
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R638
R639
R640
R641
R642
1-216-809-11
1-216-829-11
1-216-834-11
1-216-849-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
12K
220K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R643
R644
R645
R646
R647
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
1K
1.5K
1.5K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R648
R649
R650
R651
R652
1-216-827-11
1-216-829-11
1-218-867-11
1-216-833-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
4.7K
6.8K
10K
15K
5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R653
R654
R655
R656
R657
1-216-817-11
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
680
1K
1.5K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R658
R659
R660
R661
R662
1-216-825-11
1-216-827-11
1-216-829-11
1-218-867-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
4.7K
6.8K
10K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R663
R664
R665
R666
R667
1-216-837-11
1-216-817-11
1-216-819-11
1-216-821-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
470
680
1K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R668
R669
R670
R671
R672
1-216-823-11
1-216-825-11
1-216-827-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R674
R675
R676
R677
R678
1-216-835-11
1-216-835-11
1-216-835-11
1-216-864-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
15K
15K
15K
0
100K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R679
R680
R681
R682
R683
1-216-172-00
1-216-838-11
1-216-849-11
1-216-833-11
1-216-849-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
82
27K
220K
10K
220K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R684
1-216-821-11 METAL CHIP
1K
5%
1/10W
Ref. No.
Part No.
Description
R685
R686
R687
R688
R689
1-216-841-11
1-216-841-11
1-216-833-11
1-216-817-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
10K
470
4.7K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R690
R691
R692
R693
R694
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R695
R696
R697
R698
R700
1-216-809-11
1-216-809-11
1-216-809-11
1-216-182-00
1-216-182-00
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100
100
100
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/8W
R702
R704
R706
R708
R710
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
1-216-833-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
220
220
220
220
10K
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/10W
R711
R712
R713
R714
R715
1-216-833-11
1-216-797-11
1-216-797-11
1-216-809-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10
10
100
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R716
R717
R718
R719
R720
1-216-837-11
1-216-827-11
1-216-837-11
1-216-827-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
3.3K
22K
3.3K
6.8K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R721
R722
R723
R725
R727
1-216-833-11
1-216-835-11
1-216-809-11
1-216-809-11
1-220-397-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
15K
100
100
4.7M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R728
R729
R730
R731
R732
1-220-397-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7M
100
100
100
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R733
R734
R735
R736
R737
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R738
R739
R740
R741
R742
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R743
R744
R745
R746
R747
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R748
R749
R750
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
100K
5%
5%
5%
1/10W
1/10W
1/10W
69
HCD-RG333/RG441
PANEL
Ref. No.
REM
SENSOR
Part No.
Description
Part No.
Description
R751
R752
R753
R754
R755
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
S606
S607
S608
S610
S611
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (DISC 3)
SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE)
SWITCH, KEYBOARD (Z)
SWITCH, KEYBOARD (P FILE)
SWITCH, KEYBOARD (PRESET EQ)
R756
R757
R758
R759
R760
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S612
S621
S622
S623
S624
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (ENTER)
SWITCH, KEYBOARD (CD)
SWITCH, KEYBOARD (TUNER/BAND)
SWITCH, KEYBOARD (TAPE A/B)
SWITCH, KEYBOARD (GAME)
R761
R762
R763
R764
R765
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S626
S627
S628
S629
S630
1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION)
1-762-875-21 SWITCH, KEYBOARD
(PLAY MODE/TUNING MODE)
1-762-875-21 SWITCH, KEYBOARD (GAME MIXING)
1-762-875-21 SWITCH, KEYBOARD (CD SYNC)
1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)
R766
R767
R768
R769
R770
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S641
S642
S643
S644
S645
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (GROOVE)
SWITCH, KEYBOARD (SURROUND)
SWITCH, KEYBOARD (EFFECT ON/OFF)
SWITCH, KEYBOARD (TUNING +)
SWITCH, KEYBOARD (G)
R771
R772
R773
R774
R775
1-216-841-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S646
S647
S648
S649
S650
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (M ALBUM +)
SWITCH, KEYBOARD (m ALBUM –)
SWITCH, KEYBOARD (X)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (TUNING –)
R776
R777
R778
R779
R780
1-216-817-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
100
100
100
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R781
R782
R783
R784
R785
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R786
R787
R788
R789
R790
1-216-833-11
1-216-809-11
1-216-809-11
1-216-841-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
47K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R791
R792
R793
R794
R795
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R796
R797
R798
R799
R854
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R863
1-216-170-00 RES-CHIP
68
5%
1/8W
< SWITCH >
S601
S602
S603
S604
S605
70
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (?/1)
SWITCH, KEYBOARD (DISPLAY)
SWITCH, KEYBOARD (EQ BAND)
SWITCH, KEYBOARD (DISC 1)
SWITCH, KEYBOARD (DISC 2)
Ref. No.
Remark
< VIBRATOR >
X601
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
X602
1-795-004-21 VIBRATOR, CERAMIC (10MHz)
*************************************************************
REM BOARD
***********
< CONNECTOR >
CN610
1-816-423-11 SOCKET, CONNECTOR 3P
< IC >
IC610
6-600-174-01 IC RPM7240-H4 (IR)
< JUMPER RESISTOR >
JR624 1-216-296-11 SHORT CHIP
0
*************************************************************
1-687-132-12 SENSOR BOARD
**************
< CONNECTOR >
CN731
1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P
< IC >
IC731
6-600-022-01 IC RPI-576
*************************************************************
HCD-RG333/RG441
SUB TRANS
Ref. No.
Part No.
SW
Description
TRANS
Remark
X-4956-293-1 SUB TRANS BOARD, COMPLETE (RG333)
X-4956-294-1 SUB TRANS BOARD, COMPLETE
(RG441:E2,E51,AR)
X-4956-322-1 SUB TRANS BOARD, COMPLETE (RG441:MX)
**************************
< CONNECTOR >
CN901
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
< DIODE >
D901
D902
D903
D904
D905
8-719-991-33
6-500-522-21
6-500-522-21
6-500-522-21
6-500-522-21
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
10EDB40-TB3
Ref. No.
VIDEO OUT
Part No.
6 STREAM LED
Description
Remark
< CONNECTOR >
CN904
CN905
* CN905
* CN906
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
(RG333,RG441:AR,MX)
1-568-106-11 PIN, CONNECTOR (3.96mm PITCH) 4P
(RG441:E2,E51)
1-564-506-11 PLUG, CONNECTOR 3P (RG333)
1-564-508-11 PLUG, CONNECTOR 5P (RG441)
1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
* CN907
1-764-333-11 PLUG, CONNECTOR 10P
CN904
< DIODE >
D906
D908
8-719-983-79 DIODE MTZJ-T-72-27D
6-500-522-21 DIODE 10EDB40-TB3
< TRANSISTOR >
< TRANSFORMER >
Q902
0 PT902
0 PT902
0 PT902
< RESISTOR >
R903
1-249-430-11 CARBON
12K
5%
1/4W
R904
1-247-831-91 CARBON
1K
5%
1/4W
0 R908
1-202-972-61 FUSIBLE
1
5%
1/4W F
*************************************************************
< RELAY >
0 RY901
8-729-048-52 TRANSISTOR 2SA1932 (TP)
1-439-735-11 TRANSFORMER, POWER (RG333)
1-443-080-11 TRANSFORMER, POWER (RG441:MX)
1-443-239-11 TRANSFORMER, POWER (RG441:E2,E51,AR)
1-755-276-11 RELAY, POWER
< VOLTAGE SELECTOR >
VIDEO OUT BOARD
****************
0 S901
1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR)
(RG441:E2,E51)
*************************************************************
< CONNECTOR >
* CN805
1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P
1-687-669-12 SW BOARD
**********
< JACK >
< SWITCH >
J803
1-774-227-11 JACK, PIN 1P (VIDEO OUT)
*************************************************************
S751
1-786-514-11 SWITCH, LEVER (SLIDE) (OPEN)
*************************************************************
A-4750-766-A
A-4751-524-A
A-4752-191-A
A-4752-196-A
TRANS BOARD, COMPLETE (RG333)
TRANS BOARD, COMPLETE (RG441:E2,E51)
TRANS BOARD, COMPLETE (RG441:MX)
TRANS BOARD, COMPLETE (RG441:AR)
**********************
1-533-233-11 HOLDER, FUSE
6 STREAM LED BOARD
*******************
< DIODE >
LED610
LED611
LED612
LED613
LED614
6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01
LED
LED
LED
LED
LED
SELU5223C-STP15 (ILLUMINATION)
SELU5223C-STP15 (ILLUMINATION)
SELU5223C-STP15 (ILLUMINATION)
SELU5223C-STP15 (ILLUMINATION)
SELU5223C-STP15 (ILLUMINATION)
< CAPACITOR >
LED615 6-500-809-01 LED SELU5223C-STP15 (ILLUMINATION)
C906
C908
C909
C910
C911
1-164-159-11
1-128-553-11
1-126-964-11
1-126-968-11
1-126-942-61
CERAMIC
ELECT
ELECT
ELECT
ELECT
0.1uF
220uF
10uF
100uF
1000uF
20%
20%
20%
20%
50V
63V
50V
50V
25V
C920
C921
C922
C923
C924
1-131-679-31
1-131-679-31
1-131-679-31
1-131-679-31
1-136-165-00
FILM
FILM
FILM
FILM
FILM
0.01uF
0.01uF
0.01uF
0.01uF
0.1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C925
C926
1-136-165-00 FILM
1-164-159-11 CERAMIC
0.1uF
0.1uF
5%
50V
50V
< RESISTOR >
R673
R699
R701
R703
R705
1-216-837-11
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
R707
R709
1-216-182-00 RES-CHIP
1-216-182-00 RES-CHIP
22K
220
220
220
220
5%
5%
5%
5%
5%
1/10W
1/8W
1/8W
1/8W
1/8W
220
220
5%
5%
1/8W
1/8W
< ROTARY ENCODER >
S660
1-418-632-11 ENCODER, ROTARY (MASTER VOLUME)
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
71
HCD-RG333/RG441
6 STREAM LED
Ref. No.
Part No.
Description
Remark
< SWITCH >
SW601 1-786-289-11 SWITCH, DETECTION (l – EQ + L)
*************************************************************
MISCELLANEOUS
***************
6
7
7
52
53
1-400-285-11
1-769-940-11
1-777-353-11
1-796-485-51
1-769-975-11
F-BEAD, E2515MRT
WIRE (FLAT TYPE) (11 CORE) (RG441)
WIRE (FLAT TYPE) (15 CORE) (RG333)
DECK, MECHANICAL
WIRE (FLAT TYPE) (13 CORE)
54
56
0 206
0 206
0 206
1-773-048-11
1-773-317-11
1-777-071-83
1-783-941-22
1-827-226-11
WIRE (FLAT TYPE) (17 CORE)
WIRE (FLAT TYPE) (31 CORE) (RG333)
CORD, POWER (RG333,RG441:E51)
CORD, POWER (RG441:AR)
CORD, POWER (RG441:E2,MX)
252
301
0 328
329
330
1-776-182-11
1-471-035-11
8-820-244-01
1-827-992-11
1-775-251-11
WIRE (FLAT TYPE) (5 CORE)
MAGNET ASSY
OPTICAL PICK-UP (KSM-215DCP/C2RP)
WIRE (FLAT TYPE) (16 CORE)
WIRE (FLAT TYPE) (27 CORE)
0 F904
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V)
(RG441)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG333)
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V)
(RG441)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG333)
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
0 F904
0 F905
0 F905
0 F906
0 F907
0 F908
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG441)
0 F909
1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V)
(RG441)
FAN901 1-763-117-13 FAN, DC
FC901 1-469-854-11 CORE, FERRITE
M741
M751
0 PT901
0 PT901
0 PT901
A-4723-963-A
A-4736-655-A
1-443-234-11
1-443-255-11
1-443-294-11
MOTOR ASSY, TABLE (TBL)
MOTOR ASSY, LOADING (LOADING)
TRANSFORMER, POWER (RG333)
TRANSFORMER, POWER (RG441:E2,E51,AR)
TRANSFORMER, POWER (RG441:MX)
RE701
S101
TM901
TM901
1-477-680-12
1-771-853-11
1-693-615-11
1-693-616-11
ENCODER, ROTARY
SWITCH, DETECTION (LIMIT)
TUNER PACK (FM/AM) (ANTENNA) (RG441)
TUNER PACK (FM/AM) (ANTENNA) (RG333)
72
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
HCD-RG333/RG441
MEMO
73
HCD-RG333/RG441
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.
Ver.
1.0
74
Date
2004. 04
Description of Revision
New