Download Symmons 432SH Installation Guide
Transcript
432HS, 432SH, 432W Sereno™ Hand Shower/Showerhead/Hand Shower Wand Operation & Maintenance Manual Model Numbers Specifications 432HS Hand Shower Assembly 432SH Showerhead 432W Hand Shower Wand Modifications Hand shower assembly, showerhead and hand shower wand include standard 2.5 gpm (9.5 L/min) flow restrictor. Components are made from metal and nonmetallic materials plated in standard polished chrome finish. Warranty -1.5 1.5 gpm (5.7 L/min) flow restrictor -2.0 2.0 gpm (7.6 L/min) flow restrictor -STN Satin nickel finish Limited Lifetime - to the original end purchaser in consumer installations. 5 Years - for commercial installations. Refer to www.symmons.com/warranty for complete warranty information. Note: Append appropriate -suffix to model number. Symmons Industries, Inc. ■ 31 Brooks Drive ■ Braintree, MA 02184 ■ (800)796-6667 ■ Fax: (800)961-9621 ©2014 Symmons Industries, Inc.■ www.symmons.com ■ [email protected] ■ ZV-3085 REV 0 09/18/14 Dimensions 432HS Measurements A C B D A Ø 2 1/4", 57 mm B Ø 1 1/2", 38 mm C Female 1/2" IPS thread must be recessed 7/8" from finished wall D 3 1/4", 83 mm E 6", 152 mm F 7 5/16", 186 mm G 7 1/2", 191 mm H Ø 1", 25 mm 432SH E F H 432W G Note: Dimensions are subject to change without notice. 2 Symmons Industries, Inc. ■ 31 Brooks Drive ■ Braintree, MA 02184 ■ (800)796-6667 ■ Fax: (800)961-9621 ©2014 Symmons Industries, Inc.■ www.symmons.com ■ [email protected] ■ ZV-3085 REV 0 09/18/14 Parts Breakdown Replacement Parts 432HS C E D B A H F G I Item Description Part Number A J B C D E F G H Vacuum Breaker 60" Hose Wall Elbow Flange Cradle Mount Cradle Mounting Screws Washer Cradle Arm Set Screw I Hand Shower 432W K Showerhead 432SH EF-104 T-444-KIT T-545 Notes: 1) Append -STN to part number for satin nickel finish. 2) Append -1.5 or -2.0 to showerhead or hand shower for low flow. Required for Installation Adjustable wrench Phillips head screwdriver Plumber tape J 432SH 432W I K 3 Symmons Industries, Inc. ■ 31 Brooks Drive ■ Braintree, MA 02184 ■ (800)796-6667 ■ Fax: (800)961-9621 ©2014 Symmons Industries, Inc.■ www.symmons.com ■ [email protected] ■ ZV-3085 REV 0 09/18/14 Installation 1) Install wall elbow (B) and flange (C) to recessed pipe fitting. Turn elbow clockwise to tighten (432HS only). Option: Place mounting plate (D2) in position, mark and drill 3/16" holes into wall. Install anchors. 6) Install showerhead (K) to shower arm turning clockwise to tighten (432SH head only). 1 D2 1 2 C 1 B 2 K 3 2 2) Press tab to remove mounting plate (D2) from cradle mount cover (D1). 1 4) Install mounting plate (D2). Secure with two screws (E). Replace cradle mount cover (D1). D2 1 E 2 2 D1 D2 7) Attach large end of hand shower hose (J) to hand shower (I). Attach small end of hand shower hose (J) and gasket to in-line vacuum breaker (A). Connect in-line vacuum breaker to wall elbow (B). Turn clockwise to tighten. I D2 3) Place mounting plate (D2) in position, mark and drill 1/8" pilot holes into stud. D1 2 3 Note: Mounting plate (D2) center tabs must be horizontal for removal. 1 Note: Mounting plate (D2) center tabs must be horizontal for installation. J 1 B D2 2 5) Attach cradle arm (G) and washer (F) to cradle mount (D) cover. Secure with set screw (H). 3 A J D 1 2 F G 4 H Symmons Industries, Inc. ■ 31 Brooks Drive ■ Braintree, MA 02184 ■ (800)796-6667 ■ Fax: (800)961-9621 ©2014 Symmons Industries, Inc.■ www.symmons.com ■ [email protected] ■ ZV-3085 REV 0 09/18/14 4 Care and Cleaning 1) Clean finished trim area with a soft cloth using mild soap and water or a non-abrasive cleaner and then quickly rinse with water. Troubleshooting Chart 5 Problem Cause Solution Finish is spotting. Elements in water supply may cause water staining on finish. Clean finished trim area with a soft cloth using mild soap and water or a non-abrasive cleaner and then quickly rinse with water. Symmons Industries, Inc. ■ 31 Brooks Drive ■ Braintree, MA 02184 ■ (800)796-6667 ■ Fax: (800)961-9621 ©2014 Symmons Industries, Inc.■ www.symmons.com ■ [email protected] ■ ZV-3085 REV 0 09/18/14