Download Sony Ericsson CDX-CA850 User's Manual

CDX-CA850/CA850X/CA860X
SERVICE MANUAL
US Model
Canadian Model
Ver 1.1 2001. 04
CDX-CA850X/CA860X
AEP Model
UK Model
CDX-CA850
Photo: CDX-CA850X
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
Model Name Using Similar Mechanism
CDX-C5000R
CD Drive Mechanism Type
MG-383Z-121//Q
Optical Pick-up Name
KSS-720A
SPECIFICATIONS
CD player section
Power amplifier section
Signal-to-noise ratio
90 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Laser Diode Properties (US, Canadian Model)
Material
GaAlAs
Wavelength
780 nm
Emission Duration
Continuous
Laser output power
Less than 44.6 µW*
* This output is the value measured at a distance
of 200 mm from the objective lens surface on the
Optical Pick-up Block.
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
Tuner section
FM
Tuning range
87.5 – 107.9 MHz (US, Canadian model)
87.5 – 108.0 MHz (AEP, UK model)
Antenna terminal
External Antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
8 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
66 dB (stereo),
72 dB (mono)
Harmonic distortion at 1 kHz
0.6% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM (US, Canadian model)
Tuning range
530 – 1,710 kHz (US, Canadian model)
Antenna terminal
External Antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
30 µV
Tone controls
Loudness
Power requirements
Audio outputs (front/rear)
Subwoofer output (mono)
Power Antenna relay control lead
Power amplifier control lead
Telephone ATT control lead
Illumination control lead
Bus control input connector
Bus audio input connector
Remote controller input connector
Antenna input connector
Bass ±10 dB at 62 Hz (US, Canadian model)
Bass ±8 dB at 100 Hz (AEP, UK model)
Treble ±10 dB at 16 kHz (US, Canadian model)
Treble ±8 dB at 10 kHz (AEP, UK model)
+8 dB at 100 Hz
+2 dB at 10 kHz
12 V DC car battery
(negative ground)
– Continued on next page –
FM/MW/LW COMPACT DISC PLAYER
MW/LW (AEP, UK model)
Tuning range
MW: 531 – 1,602 kHz
LW: 153 – 279 kHz
Aerial terminal
External Aerial connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
MW: 30 µV
LW: 40 µV
9-870-291-12
Sony Corporation
2001D0400-1
© 2001. 4
e Vehicle Company
Shinagawa Tec Service Manual Production Group
CDX-CA850
FM/AM COMPACT DISC PLAYER
CDX-CA850X/CA860X
1
CDX-CA850/CA850X/CA860X
Dimensions
Mounting dimensions
Mass
Supplied accessories
Approx. 178 × 50 × 177 mm
(7 1/8 × 2 × 7 in.) (w/h/d)
Approx. 182 × 53 × 162 mm
(7 1/4 × 2 1/8 × 6 1/2 in.) (w/h/d)
Approx. 1.3 kg
(2 lb. 10 oz.)
Parts for installation and connections (1 set)
Front panel case (1)
Rotary commander
RM-X5S
Card remote commander
RM-X112 (CDX-CA850X/CA860X)
RM-X113 (CDX-CA850)
Note
This unit cannot be connected to a digital preamplifier or an equalizer.
Design and specifications are subject to change without
notice.
SERVICE NOTES
• US, Canadian model
• AEP, UK model
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
This label is located on the bottom of the chassis.
optical pick-up block
This label is located on the drive unit's internal
chassis.
When replacing the chassis (T.U) of mechanism deck which have
the “CAUTION LABEL” attached, please be sure to put a new
CAUTION LABEL (3-223-913-11) to the chassis (T.U).
semi-fixed resistor
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
2
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
CDX-CA850/CA850X/CA860X
Ver 1.1 2001. 04
TABLE OF CONTENTS
1. GENERAL ........................................................................... 4
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................. 10
2-2. CD Mechanism Block ....................................................... 10
2-3. Main Board ....................................................................... 10
2-4. Heat Sink ........................................................................... 11
2-5. Chassis (T) Assy ................................................................ 11
2-6. Lever Section ..................................................................... 12
2-7. Servo Board ....................................................................... 12
2-8. Arm Roller Assy ................................................................ 13
2-9. Chassis (OP) Assy ............................................................. 13
2-10. Optical Pick-up Block ....................................................... 14
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 15
3-2. Block Diagram –CD Section– ........................................... 23
3-3. Block Diagram –Tuner Section– ....................................... 24
3-4. Block Diagram –Display Section– .................................... 25
3-5. Circuit Boards Location .................................................... 26
3-6. Printed Wiring Boards –CD Mechanism Section– ............ 28
3-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 30
3-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 31
3-9. Printed Wiring Boards –Main Section– ............................ 32
3-10. Schematic Diagram –Main Section (1/4)– ........................ 34
3-11. Schematic Diagram –Main Section (2/4)– ........................ 35
3-12. Schematic Diagram –Main Section (3/4)– ........................ 36
3-13. Schematic Diagram –Main Section (4/4)– ........................ 37
3-14. Printed Wiring Board –Sub (CD) Section– ....................... 38
3-15. Schematic Diagram –Sub (CD) Section– .......................... 39
3-16. Printed Wiring Board –Key Section– ................................ 40
3-17. Schematic Diagram –Key Section– ................................... 41
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
Chassis Section ................................................................. 46
Front panel Section ........................................................... 47
CD Mechanism Section (1) ............................................... 48
CD Mechanism Section (2) ............................................... 49
CD Mechanism Section (3) ............................................... 50
5. ELECTRICAL PARTS LIST ........................................ 51
3
CDX-CA850/CA850X/CA860X
SECTION 1
GENERAL
4
This section is extracted from AEP,
UK model’s instruction manual.
CDX-CA850/CA850X/CA860X
5
CDX-CA850/CA850X/CA860X
6
CDX-CA850/CA850X/CA860X
7
CDX-CA850/CA850X/CA860X
8
CDX-CA850/CA850X/CA860X
Connection
9
9
CDX-CA850/CA850X/CA860X
SECTION 2
DISASSEMBLY
Note : This equipment can be removed using the following procedure.
Set
Sub Panel Assy
Chassis (T) Assy
CD Mechanism Block
lever Section
2-2. CD MECHANISM BLOCK
Main Board
7 bracket (CD)
Heat Sink
6 PTT 2.6x4
5 CD mechanism block
Arm Roller Assy
Servo Board
Chassis (OP) Assy
Optical Pick-up Block
2 PTT 2.6x4
3
1 PTT 2.6x4
4 CN401
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
2-3. MAIN BOARD
6 MAIN board
4 two claws
4 ground point screw
(PTT 2.6x6)
5 ground point screws
(PTT 2.6x6)
6 sub panel assy
3 PTT 2.6x4
2 PTT 2.6x6
3 claw
2 PTT 2.6x4
5 CN701
1 PTT 2.6x4
1 PTT 2.6x6
10
10
CDX-CA850/CA850X/CA860X
2-4. HEAT SINK
5 heat sink
3 PTT 2.6x10
2 PTT 2.6x16
1 PTT 2.6x10
4 PTT 2.6x4
2-5. CHASSIS (T) ASSY
2 P 2x3
3 P 2x3
1 Unsolder the
lead wires.
4 chassis (T) assy
black
red
white
11
CDX-CA850/CA850X/CA860X
2-6. LEVER SECTION
5 guide (disc)
6 lever (R) sub assy
3 tension spring (LR)
7 lever (L) sub assy
1 PS 2x4
2 DISC IN board
4 claws
2-7. SERVO BOARD
9 PS 2x4
1 PS 2x5
2 heat sink (CD)
7 PS 2x4
5 Removal the solders.
4 CN2
3 CN3
7 P 2x3
0 SERVO board
6 Removal the solders.
8 loading motor assy
(M903)
12
CDX-CA850/CA850X/CA860X
2-8. ARM ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
retaining ring (roller)
arm
bearing (roller)
washer(RA)
washer(RA)
bearing (roller)
arm
Fig. 1
2 arm roller assy
3 PS 2x3
4 LOAD board
1 tension spring (RA2)
2-9. CHASSIS (OP) ASSY
7 chassis (OP) assy
8 compression spring (FL)
1 tension spring (KF1)
9 compression spring (FL)
2 tension spring (KR1)
5 Fit lever (D) in the
direction of the arrow.
6 Turn loading ring in the
direction of the arrow.
3 damper (T)
4 damper (T)
13
CDX-CA850/CA850X/CA860X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy
(M902)
3 optical pick-up block
14
CDX-CA850/CA850X/CA860X
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC501 CXD2598Q (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) (SERVO BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
DVDD
—
Digital power supply pin
2
3
DVSS
SOUT
—
O
Digital ground
Servo brock serial data output (Not used.)
4
5
SOCK
XOLT
O
O
Servo brock serial data read clock output (Not used.)
Servo brock serial data latch output (Not used.)
6
7
SQSO
SQCK
O
I
Sub Q 80 bit, PCM peak and level data output. CD TEXT data output
Clock input from SQSO read output.
8
9
SCSY
SBSO
I
O
Fixed at “L”.
Serial output of sub-P to W. (Not used.)
10
11
EXCK
XRST
I
I
Clock input from SBSO read output. (Fixed at “L”)
System reset (“L”: Reset)
12
13
STSM
DATA
I
I
System mute input (Fixed at “L”)
Serial data input from CPU.
14
15
XLAT
CLOK
I
I
Latch input from CPU. Latch serial data at the falling edge.
Serial data transfer clock input from CPU.
16
17
SENS
SCLK
O
I
SENS output for CPU.
Clock input from SENS serial data read.
18
19
ATSK
WFCK
I/O
O
20
21
XUGF
XPCK
O
O
XUGF output (Not used.)
XPCK output (Not used.)
22
23
24
GFS
C2PO
SCOR
O
O
O
GFS output
C2PO output (Not used.)
“H” output at either detection, sub code sync S0 or S1.
25
26
C4M
WDCK
O
O
4.2336 MHz output (Not used.)
Word clock input f=2Fs (Not used.)
27
28
COUT
MIRR
I/O
I/O
Track number count signal input/output (Not used.)
Mirror signal input/output (Not used.)
29
30
DVSS
DVDD
—
—
Digital ground
Digital power supply pin
31
32
DFCT
FOK
I/O
I/O
Diffect signal input/output (Not used.)
Focus OK signal output
33
34
PWM1
LOCK
I
I/O
External control input of spindle motor.
Lock signal input/output
35
36
MDP
SSTP
O
I
37
38
FSTIO
SFDR
I/O
O
39
40
SRDR
TFDR
O
O
Sled drive output
Tracking drive output
41
42
TRDR
FFDR
O
O
Tracking drive output
Focus drive output
43
44
FRDR
DVDD
O
—
Focus drive output
Digital power supply pin
45
46
DVSS
TEST
—
I
Digital ground
Test pin (Fixed at “L”)
47
48
TES1
XTSL
I
I
Test pin (Fixed at “L”)
X’tal select input (“L”: 16.9344 MHz, “H”: 33.8688 MHz)
49
50
VC
FE
I
I
Center voltage input
Focus error signal input
51
SE
I
Sled error signal input
Input/output for anti-shock.
WFCK (Write Flame Clock) output (Not used.)
Servo control output of spindle motor.
Disc most inner track detection signal input
2/3 frequency division output of pins ih and ij. (Not used.)
Sled drive output
15
CDX-CA850/CA850X/CA860X
Pin No.
52
Pin Name
TE
I/O
I
Tracking error signal input
53
54
CE
RFDC
I
I
Center servo analog input
RF signal input
55
56
ADIO
AVSSO
O
—
Test pin (Not used.)
Analog ground
57
58
IGEN
AVDDO
I
—
Constant current input from OP amplifier.
Analog ground
59
60
ASYO
ASYI
O
I
EFM full-swing output (“L”: VSS, “H”: VDD)
Asymmetry comparate voltage input
61
62
RFAC
AVSS3
I
—
EFM signal input
Analog ground
63
64
CLTV
FILO
I
O
VCO control voltage input from master.
Filter output for master PLL (slave=digital PLL)
65
66
FILI
PCO
I
O
Filter input from master PLL.
Charge pump output for master PLL.
67
68
AVDD3
BIAS
—
I
Analog power supply pin
Asymmetry circuit constant current input
69
70
VCTL
V16M
I
O
VCO2 control input from wideband EFM PLL. (Not used.)
VCO2 oscillator output for wideband EFM PLL. (Not used.)
71
72
VPCO
DVSS
O
—
Charge pump output for wideband EFM PLL. (Not used.)
Digital ground
73
74
MD2
DOUT
I
O
Digital out ON/OFF control input (“L”: OFF, “H”: ON)
Digital out output
75
76
77
ASYE
DVDD
LRCK
I
—
O
Asymmetry circuit ON/OFF input (“L”: OFF, “H”: ON)
Digital power supply pin
D/A interface LR clock output (f=Fs)
78
79
LRCKI
PCMD
I
O
D/A interface LR clock input
D/A interface serial data output (2’s COMP, MSB fast)
80
81
PCMDI
BCK
I
O
D/A interface serial data input (2’s COMP, MSB fast)
D/A interface bit clock output
82
83
BCKI
EMPH
I
O
D/A interface bit clock input
Emphasis ON/OFF signal output
84
85
EMPHI
XVDD
I
—
Emphasis ON/OFF signal input (“H”: ON, “L”: OFF)
Power supply for master clock.
86
87
XTAI
XTAO
I
O
X’tal oscillator input from master clock (16.9344 MHz).
X’tal oscillator output for master clock (16.9344 MHz).
88
89
XVSS
AVDD1
—
—
Ground pin for master clock.
Analog power supply pin
90
91
AOUT1
AIN1
O
I
Lch analog output
Lch OPAMP input
92
93
LOUT1
AVSS1
O
—
Lch LINE output
Analog ground
94
95
AVSS2
LOUT2
—
O
Analog ground
Rch LINE output
96
97
AIN2
AOUT2
I
O
Rch OPAMP input
Rch analog output
98
99
AVDD2
RMUT
—
O
Analog power supply pin
Rch “0” detect Flug (Not used.)
100
LMUT
O
Lch “0” detect Flug (Not used.)
16
Pin Description
CDX-CA850/CA850X/CA860X
• IC5 CXP84640-072Q (CD SYSTEM CONTROL) (SERVO BOARD)
Pin No.
Pin Name
I/O
1
ITRPT
—
Not used in this set.
Pin Description
2, 3
4, 5
—
NCO
—
—
Not used in this set.
Not used in this set.
6
7
OPEN
CLOSE
I
O
Front panel open detection input
Front panel close control output
8
9
LINKOFF
NCO
I
—
Bus interface link input
Not used in this set.
10
11
D SW
SSTP
I
I
12, 13
14, 15
NCO
—
—
—
Not used in this set.
Not used in this set.
16
17
EMPH O
CDMON
O
O
De-emphasis ON/OFF control output
CD mechanism deck power control output
18
19
CD ON
A MUT
O
O
CD power control output
System attenuate control output
20
21
LD ON
CD RST
O
O
Laser power ON/OFF control output
CD system reset output
22
23
HOLD
AGC CONT
O
O
Hold switch output
AGC control output
24
25
—
PH3
—
I
Not used in this set.
Not used in this set.
26
27
TSTIN0
TSTIN1
I
I
Not used in this set.
Not used in this set.
28
29
30
TST.CLV
NCO
RESET
I
—
I
Not used in this set.
Not used in this set.
System reset input (“L”=Reset)
31
32
X IN
X OUT
I
O
X’tal oscillator input from system clock. (10 MHz)
X’tal oscillator output for system clock. (10 MHz)
33
34
GND
XT OUT
—
O
Analog ground
Not used in this set.
35
36
XT IN
AVSS
I
—
Not used in this set.
A/D converter ground
37
38
AVREF
TEP L
I
I
A/D converter reference voltage input
Not used in this set.
39
40
TEP H
SLED–
I
I
Not used in this set.
Sled drive input
41
42
PH2
SEK/SMET
I
I
Not used in this set.
Fixed at “H” in this set.
43
44
GFS/MNT2 SEL
SC-JIG ON/OFF
I
I
Fixed at “H” in this set.
Fixed at “H” in this set.
45
46
SCLK
LOCK
O
I/O
CD-TEXT data read clock output
Lock signal input/output
47
48
—
SCK2
—
O
Not used in this set.
Sub Q read clock output
49
50
SI2
—
I
—
Sub Q 80 bit, PCM peak and level data 16 bit input.
Not used in this set.
51
52
BUS CLK
BUS SI
I/O
I
Bus system serial clock input/output
Bus system serial interface input
53
54
BUS SO
F OK
O
I
Bus system serial interface output
Focus OK signal input
55
56
GFS
TEST MODE
I
I
GFS signal detection input
Fixed at “H” in this set.
Down switch input (SW4)
Limit switch input (SW3)
17
CDX-CA850/CA850X/CA860X
Pin No.
57
Pin Name
SENS
I/O
I
SENS signal input
58
59
—
—
—
—
Not used in this set.
Not used in this set.
60
61
BU.IN
BUSON
I
I
Back-up power detection input
Bus on control input
62
63
IN SW
SELF SW
I
I
Disc in switch input (SW1)
Self switch input (SW2)
64
65
SCOR
CD-CKO
O
O
Sub-code sync output
CD signal process serial clock input
66
67
LM LOD
CD DATA
O
O
Loading motor control output
CD signal process serial data output
68
69
CD-XLAT
LM-EJ
O
O
CD signal process serial data latch output
Loading motor control output
70
71
DRV-OE
MD2
O
O
Focus/tracking coil/sled motor control output
Digital out ON/OFF control output (“L”: OFF, “H”: ON)
72
73
VDD
NIH
—
I
Power supply pin
Fixed at “H” in this set.
74
75
V/Z
PH1
I
I
Fixed at “H” in this set.
Not used in this set.
76
77
—
DOUT-SEL
—
I
Not used in this set.
Fixed at “H” in this set.
78 – 80
—
—
Not used in this set.
18
Pin Description
CDX-CA850/CA850X/CA860X
• IC501 MB90574BPMT-G-323-BND (MAIN SYSTEM CONTROL) (CDX-CA850X/CA860X) (MAIN BOARD)
• IC501 MB90574BPMT-G-324-BND (MAIN SYSTEM CONTROL) (CDX-CA850) (MAIN BOARD)
Pin No.
Pin Name
I/O
Pin Description
1–4
NCO
O
Not used. (Open)
5
6, 7
ATT
NCO
O
O
System mute control signal output
Not used. (Open)
8
9
VCC
AMP ATT
—
O
Power supply pin (+5 V)
Amp mute signal output
10
11
E2PSIO
E2PCKO
I/O
O
EEPROM data signal input/output
EEPROM clock signal output
12
13
DOOR SW/FLS SI
FLS SO
I
O
Door switch signal input (L: close) Flash write data signal input
Flash write data signal output
14
15
BUS ON
BEEP
O
O
BUS ON control signal output
Beep signal output
16
17
NS MASK
UNISI
O
I
Tuner mute signal output
SONY BUS data signal input
18
19
UNISO
UNICKO
O
O
SONY BUS data signal output
SONY BUS clock signal output
20
21
IFWIDTH
SWSHIFT
O
O
Not used. (Open)
Not used. (Open)
22
23
SYSRST
(NCO)
O
O
System reset signal output
Not used. (Open)
24
25 – 29
SIRCS
NCO
I
O
Remote control data signal input
Not used. (open)
30
31
32
AMPON
VOLATT
NCO
O
O
O
Amp on signal output (L: OFF/H: ON)
Electronic volume mute signal output (L: Mute on)
Not used. (Open)
33
34
VSS
C
—
—
Ground pin
Power stabilized capacitance pin Not used. (open)
35 – 37
38
NCO
DVCC
O
—
Not used. (Open)
D/A converter VREF input
39
40, 41
DVSS
(NCO)
—
O
D/A converter GND pin
Not used. (Open)
42
43
AVCC
AVRH
—
—
Analog power supply pin (+5 V)
A/D converter VREF+ input
44
45
AVRL
AVSS
—
—
A/D converter VREF– input
Analog ground pin
46
47
KEYIN0
KEYIN1
I
I
Key signal input 0
Key signal input 1
48
49
RCIN0
NCO
I
O
Rotary commander signal input
Not used. (Open)
50
51
QUALITY
FM AGC
O
O
Quality signal output
Not used in this set. (Open)
52
53
MPTH
VSM
O
I
MPTH signal output to RDS decoder
S-meter signal input
54
55, 56
VCC
NCO
—
O
Power supply pin (+5 V)
Not used. (Open)
57
58
BOOT
DOORIND
O
O
Display microcomputer write control signal output
Front panel indicator signal output
59 – 62
63
NIL
VSS
I
—
Not used. (Connect to ground in this set.)
Ground pin
64
65
NIL
FSW IN
I
O
Not used. (Connect to ground in this set.)
Not used. (Open)
66 – 68
NCO
O
Not used. (Open)
19
CDX-CA850/CA850X/CA860X
Pin No.
69
Pin Name
FLASH W
I/O
I
70
71
I2CSIO
I2CCKO
O
O
Tuner, electronic volume communication data signal output
Tuner, electronic volume communication clock signal output
72
73
NCO
X1A
O
I
Not used. (Open)
Low speed oscillation signal input (32.768 kHz)
74
75
X0A
DAVN
I
O
Low speed oscillation signal input (32.768 kHz)
DAVN signal output to RDS decoder
76
77
DISCON IN
BUIN
O
I
Not used. (Open)
Backup power supply detection signal input
78
79
NCO
KEYACK
O
I
Not used. (Open)
KEY ACK detection signal input
80
81
ADON
NOSESW
O
I
A/D conversion power control signal output
Front panel attachment detection signal input
82
83
FLASH ON
PWON
O
O
Flash write jig power supply output
System power supply control signal output
84
85
NCO
RAMBU
O
I
Not used. (Open)
RAM reset detection signal input
86
87
HSTX
MD2
I
I
Hardware standby signal input
Operation mode input (Connect to ground.)
88, 89
90
MD1, 0
RESET
I
I
Operation mode input (Connect to VCC.)
Microcomputer reset signal input
91
92
VSS
X0
—
I
Ground pin
High speed oscillation signal input (3.68 MHz)
93
94
95, 96
X1
VCC
REIN0, 1
I
—
I
High speed oscillation signal input (3.68 MHz)
Power supply pin (+5 V)
Rotary encoder signal input
97 – 99
100
NCO
4V SEL X/O
O
I
Not used. (Open)
4 V/5.5 V preout menu with/without initial setting input
101
102
COLORSEL X/O
MODELSEL0 U/J
I
I
Illumination select with/without initial setting input Not used. (Open)
Destination setting input Not used. (Open)
103
104
DOT/L-CUBE
CD/MD
I
I
DOT/L-CUBE judgment initial setting input
CDX/MDX judgment initial setting input Not used. (Open)
105, 106
107
NCO
RCIN1 (PULL UP)
O
I
Not used. (Open)
Rotary commander signal input
108
109
TESTIN (PULL UP)
TELATT
I
I
Test mode setting detection input
TEL mute detection signal input
110
111, 112
ILLIN
NCO
I
O
Illumination line detection signal input
Not used. (Open)
113
114, 115
TUNON
NCO
O
O
Tuner on signal output
Not used. (Open)
116
117
EMPH
ACCIN
O
I
Not used. (Open)
ACC power supply detection signal input L: ACC ON
118
119
NCO
VSS
O
—
Not used. (Open)
Ground pin
120
NCO
O
Not used. (Open)
20
Pin Description
Flash write mode detection signal input
CDX-CA850/CA850X/CA860X
• IC701 HD6432355A35F (SUB SYSTEM CONTROL)
Pin No.
Pin Name
I/O
1
PG3
O
Spectrum analyzer clock output
Pin Description
2
3
PG4
VSS
O
—
Not used (open)
Ground pin
4
5
NC
VCC
—
—
Not used (open)
Power supply pin
6–9
10
PC0 – PC3
VSS
O
—
Not used (open)
Ground pin
11 – 14
15 – 18
PC4 – PC7
PB0 – PB3
O
O
Not used (open)
Not used (open)
19
20 – 23
VSS
PB4 – PB7
—
O
Ground pin
Not used (open)
24 – 27
28
PA0 – PA3
VSS
O
—
Not used (open)
Ground pin
29 – 32
33
PA4 – PA7
SP LAT(PWON)
O
I
Not used (open)
Spectrum analyzer latch input
34
35
BU IN
VSS
I
—
Back-up power detection input
Ground pin
36
37
VSS
P65
—
O
Ground pin
Not used (open)
38
39
BUS ON
VCC
I
—
Bus on control signal
Power supply pin
40 – 43
44
PE0 – PE3
VSS
O
—
Not used (open)
Ground pin
45 – 48
49
50
PE4 – PE7
PD0
LINK OFF
O
O
O
Not used (open)
Not used (open)
Bus interface link off control signal
51
52
PD2
ILL-ON
O
O
Not used (open)
Illumination on/off switch signal output
53
54 – 56
VSS
PD4 – PD6
—
O
Ground pin
Not used (open)
57
58
BOOT
VCC
I
—
Flash write-in mode detection input
Power supply pin
59
60
NC
TX/LCD DATA
—
O
Not used (open)
Flash write-in data/LCD driver data output
61
62
SP SI
RX
O
I
Not used (open)
Flash write-in data input
63
64
L RST
LCD SCK
O
O
Reset signal for SIRCS inveter
LCD driver clock output
65
66
VSS
LCD CE1
—
O
Ground pin
LCD driver chip enable output
67
68
VSS
VSS
—
—
Ground pin
Ground pin
69
70
LCD INH1
LCD CE2
O
O
Not used (open)
Not used (open)
71
72 – 78
LCD INH2
P27 – P21
O
O
Not used (open)
Not used (open)
79
80
P20
FWE L
O
I
Flash write-in control signal
Flash write-in enable input
81
82
RES
NMI
I
I
Reset signal
Non maskable interrupt signal
83
84
STBY
VCC
—
Standby mode signal
Power supply pin
21
CDX-CA850/CA850X/CA860X
Pin No.
85
Pin Name
XTAL
I/O
—
Crystal oscillator (18.432 MHz)
86
87
EXTAL
VSS
—
—
Crystal oscillator (18.432 MHz)
Ground pin
88
89
PF7
VCC
O
—
Not used (open)
Power supply pin
90 – 96
97
PF6 – PF0
UNI SO
O
O
Not used (open)
SONY Bus data output
98
99
UNI SI
VSS
I
—
SONY Bus data input
Ground pin
100
101
VSS
UNI SCK
—
I
Ground pin
SONY Bus clock input
102
103
P53
AVCC
O
—
Not used (open)
Power supply pin for A/D converter
104
105 – 111
VREF
P42 – P46
—
O
Reference voltage for A/D converter
Not used (Connecting to ground.)
112
113
P47(SA DATA)
AVSS
I
—
Spectrum analyzer data input
Ground pin
114
115 – 122
VSS
P17 – P10
—
O
Ground pin
Not used (open)
123
124
MD0
MD1
—
—
Mode select
Mode select
125
126 – 128
MD2
PG0 – PG2
—
O
Mode select
Not used (open)
22
Pin Description
CDX-CA850/CA850X/CA860X
3-2. BLOCK DIAGRAM — CD SECTION —
4
RF AMP, LD APC,
ERROR AMP
IC1
OPTICAL PICK-UP
KSS-720A
DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC501
(Page 24)
1
A
A
5
C
B
C
7
B
6
TUNER
SECTION
RF
EQ
RFO
16
61
RFAC
EFM
DEM
D/A
I/F
D/A
CONV.
LOUT1
92
LOUT2
95
D
I-V
CONV.
8
CDMON 17
CDON 18
R-CH
FOCUS
ERROR
DIGITAL
CLV
LOCK
46 LOCK
34
(KEY BOARD)
FE
E
F
PD
4
TRACKING
ERROR
TE
LD
DRIVE
Q101
3
14
50
13
52
51
PD
6 OPEN
FE
TE
SUB
CODE
PROCESS
SE
MD2
XRST
DATA
XLAT
SCLK
CLOK
SENS
GFS
FOK
LD ON
22
HOLD SW 21
AGC CONT 20
LD
TRACKING/FOCUS COIL DRIVE
SLED/SPINDLE/LOADING MOTOR DRIVE
IC7
10
FOCUS
COIL
11
FOCUS
COIL
DRIVE
22
42
21
43
25
40
9
TRACKING
COIL
DRIVE
24
41
M902
SLED
MOTOR
6
7
SLED
MOTOR
DRIVE
31
32
38
39
M901
SPINDLE
MOTOR
12
13
SPINDLE
MOTOR
DRIVE
8
TRACKING
COIL
SQSO
SQCK
SCOR
6
7
24
49 SI2
48 SCK2
64 SCOR
73
11
13
14
17
15
16
22
32
71
21
67
68
45
65
57
55
54
:CD
MDON
CDON
5
DISPLAY
SECTION (Page 25)
19
17
18
14
22
77
BUS ON 61
RESET 30
BU IN 60
UNI CKO
UNI SI
UNI SO
BUS ON
SYS RST
BU IN
18
35
FFDR
X1
10MHz
FRDR
TFDR
TRDR
SERVO
CTL
SFDR
SRDR
MDP
MD2
CD RST
CD DATA
CD XLAT
SCLK
CD CKO
SENS
GFS
FOK
BU 5V
1 RESET 2
S101
RESET
BU DET
Q602
BUS INTERFACE
IC601
5
4
LOADING
MOTOR
DRIVE
32 XOUT
SW3
(LIMIT)
11 SSTP
SW1
(DISC IN)
62 IN SW
SW4
(DOWN)
10 D SW
10
BATT (L)
CHECK
3
13
RESET
2
12
BUS ON
CONT
1
BATT
Q603
SW2
(SELF)
8
9
63 SELF SW
1
2
69
66
40
70
20
22
23
MUTE 1 34
MUTE 2 35
LM EJ
LM LOD
SLED –
DRIVE OE
LD ON
HOLD
AGC CONT BUS SO 53
2
DISPLAY
SECTION
(Page 25)
23
BATT
31 XIN
DATA
6
8
M903
LOADING
MOTOR
SIRCS
BUFFER
IC903
90 RESET SIRCS 24
86 HSTX
IC502
LD
AMP
LD
• Signal path
5 ATT
BUS CLK 51
BUS SI 52
D
E
11
F
10
SYSTEM CONTROL
IC501 (1/3)
A MUT 19
CD L
54 RFDC
ATT
CD SYSTEM CONTROL
IC5
TUNER
SECTION
(Page 24)
23
SRST
BUS CLK
BUS SI
BUS ON
UNI SO
LINK OFF
11
CLK
6
5
4
3
2
1
7
4
CN601
BUS
CONTROL IN
CDX-CA850/CA850X/CA860X
3-3. BLOCK DIAGRAM — TUNER SECTION —
CN302
–1
CA850/CA850X
1
CDL
CD
SECTION
(Page 23)
4 AUXL
ADSO(L-CH)
IC304
3
CA860X
ELECTRONIC VOLUME
IC301
OUT FL 28
3
1
2
R-CH
–5
13
Q306
43 MDL
1
BUFFER
IC308
33 AC INL
38 ACOUTL
OUT RL 27
5
R-CH
BUFFER
IC302
7
7
–2
–6
–3
12
Q308
TUNER UNIT
TUX201
R-CH
–4
L
BUS AUDIO IN
R
L
R
L
R
AUDIO OUT
FRONT
AUDIO OUT
REAR
CN201
(ANTENNA)
1 AM ANT
MPX 10
2 FM ANT
AMDET 8
12 MPX1
9
16
14
19
20
17
CA850
AM
QUAL
MP IN
SDA
SCL
SM
CA850/CA850X
1
OUTSW 24
2
Q205
RDS DET 9
16 MPX
MPT 2
8
10
9
20
L
SUB OUT
POWER AMP
IC351
CA850/CA850X
4
CD
SECTION
(Page 23)
31 VOL ATT
50 QUALITY
ATT
Q310
MUTE
CONTROL
Q303, 304
1
52 MPTH
75 DAIN
9
3
3
DISPLAY
SECTION
(Page 25)
SDA EEPROM 17
SCL EEPROM 18
10 E2PSIO
11 E2PCKO
RL+
10
RL–
7
POWER
CONT.
Q104(1/2),105
4 STBY
Q103
ACC
DET
Q101
X501
32.768kHz
R-CH
ILL
DET
Q102
TEST 108
PW ON 83
XO 92
XI 93
FL–
11
AMP ON 30
XDA 74
53 VSM
70 I2CSIO
71 I2CCKO
2
9
16 BEEP
22 MUTE
TEL ATT 109
ILL IN 110
ACC IN 117
XIA 73
S METER 14
SDA IIC 12
SCL IIC 13
FL+
5
BEEP 15
AMP ATT 9
BATT
CN101
12
SA CLK
SA OUT
PWON
16 NS MASK
RDS DECODER
IC201
DAVN
SCA
SDA
LVIN
CN301
4
R
SYSTEM CONTROL
IC501 (2/3)
NOISE
7
DET
CA860X
SA CLK 21
SA OUT 23
IC202
RF AMP
Q204
SUB WOOFER AMP
IC310
X502
3.68MHz
BATT
POWER
CONT
Q801-803
COM 8.5V
POWER
CONT
Q201,202
TU 8V
POWER
CONT.
Q104(2/2),106
BATT
4
FR+
12
FR–
3
RR+
11
RR–
13
TEL MUTE
14
ILL
7
ACC
15
TEST
5
AMP REM
6
ANT REM
TUN ON 113
• Signal path
COM8.5V
:CD
+5V
REG
Q207
:FM
:AM/MW/LW
CA860X
TU 5V
1
24
24
16
BATT
+10V
REG
IC801
3
10V
BATT
CDX-CA850/CA850X/CA860X
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
SYSTEM CONTROL
IC501 (3/3)
SUB SYSTEM CONTROL
IC701
98 UNI SI
BUS SI
97 UNI SO
UNI SO
2
CD
SECTION
(Page 23)
101 UNI SCK
38 BUS ON
50 LINK OFF
BUS CLK
BUS ON
LINK OFF
BUF
6 IC702 7
S RST
81 RES
80 ADON
XTAL 85
EXTAL 86
X701
18.432MHz
KEY
ACTIVE
Q701
79 KEY ACK
CA850
3
TUNER
SECTION
(Page 24)
PW ON
33 PW ONI
SA CLK
1 SA CLK
SA OUT
112 SA OUT
107 RC IN1
J651
(REMOTE IN)
48 RC IN0
46 KEY IN0
47 KEY IN1
KEY IN
MATRIX
BOOT 57
57 BOOT
ILL ON 52
82 FLASH ON
LCD DRIVER
IC901
BATT
60 LCD DATA
64 LCD SCK
66 LCD CE1
DATA 100
CLK 99
CE 98
LCD+B
DIMMER
LCD901
POWER
CONT.
Q702,703
86
LED851
DIMMER
CONTROL
Q903
LED
DRIVE
Q705,706
58 DOOR IND
MD ON
CD ON
LSW921
LED910-913
S102
(NOSE DET)
81 NOSESW
BATT
POWER
CONT.
Q402,403
+6V REG
Q401
POWER
CONT.
Q405,407
CD 6V
LCD+B
BATT
REG
Q501
BU5V
25
25
+5V REG
Q406
CD 5V
5
CD
SECTION
(Page 23)
CDX-CA850/CA850X/CA860X
3-5. CIRCUIT BOARDS LOCATION
DISC IN board
SUB board
SUB (CD) board
LIMIT board
tuner unit
(TUX201)
MAIN board
LOAD board
KEY board
26
26
SERVO board
CDX-CA850/CA850X/CA860X
• Waveforms
— Servo Board —
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
1
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
1
5Vp-p
0V
Approx. 200mVp-p
IC1
4.332MHz
(TE)
qd
(OSCD)
4
IC201
2
2
5.1Vp-p
0V
Approx. 620mVp-p
IC1
32.768kHz
(FE)
qf
IC501
3
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM/MW/LW
J : CD
uf
(X0A)
3
2.2Vp-p
1.2Vp-p
3.68MHz
IC1
qh
(RFO)
IC501
4
os
(XO)
4
1.6Vp-p
1.4Vp-p
18.432MHz
16MHz
IC501
(XTAI)
ih
5
4.2Vp-p
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
— Main Board —
(MODE: CD PLAY)
10MHz
IC5
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
ea
(X IN)
— Key Board —
1
4.6Vp-p
4MHz
IC903
27
27
4
(XOUT)
IC701
ih
(EXTAL)
CDX-CA850/CA850X/CA860X
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION —
28
28
CDX-CA850/CA850X/CA860X
• Semiconductor
Location
(Page 33)
29
29
Ref. No.
IC1
IC5
IC7
IC501
Location
C-2
C-6
F-2
F-5
Q101
B-2
CDX-CA850/CA850X/CA860X
• Refer to page 27 for Waveforms.
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 42 for IC Block Diagrams.
IC B/D
(Page 31)
(Page 36)
Note:
• Voltage is dc with respect to
ground under no-signal conditions.
no mark : CD PLAY
(Page 31)
30
30
CDX-CA850/CA850X/CA860X
• Refer to page 27 for Waveforms.
3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 42 for IC Block Diagrams.
(Page 30)
IC B/D
(Page 30)
Note:
• Voltage is dc with respect to
ground under no-signal conditions.
no mark : CD PLAY
31
31
CDX-CA850/CA850X/CA860X
3-9. PRINTED WIRING BOARDS — MAIN SECTION —
• Semiconductor Location
Ref. No. Location
Ref. No.
D102
C-5
IC310
D105
D-7
IC502
D106
C-7
IC601
D107
C-5
IC702
D110
E-5
IC801
D202
G-12
D203
G-12
Q101
D204
I-11
Q102
D310
G-8
Q103
D311
H-7
Q104
D501
K-5
Q105
D504
K-6
Q106
D505
K-7
Q201
D601
D-4
Q202
D603
C-2
Q204
D607
E-3
Q205
D608
D-3
Q207
D609
D-3
Q303
D610
D-4
Q304
D653
K-9
Q402
D703
K-13
Q403
D707
K-13
Q405
D715
J-4
Q407
D802
H-10
Q602
Q603
IC201
I-13
Q701
IC202
H-11
Q702
IC302
D-11
Q703
IC303
D-10
Q705
IC305
F-11
Q706
IC308
E-11
Q802
IC309
E-10
Q803
CA860X
32
32
Location
D-12
K-6
D-3
J-10
H-10
C-4
D-5
B-5
C-6
C-6
C-5
G-11
G-12
G-11
H-11
H-12
G-8
G-7
H-2
H-2
G-3
G-4
C-3
C-3
K-8
J-3
J-4
K-3
K-4
G-2
F-2
CDX-CA850/CA850X/CA860X
AEP,UK model
PERK
LIGHT GREEN
US,Canadian model
(Page 29)
• Semiconductor
Location
(Page 38)
33
33
Ref. No.
D101
D301
D302
D303
D304
D305
D306
D307
D308
D401
D402
D503
D604
D605
D606
D708
D801
Location
B-4
B-7
B-7
B-6
B-6
C-7
B-8
C-8
C-8
G-2
H-3
I-2
B-2
B-2
B-2
K-11
G-2
IC301
IC304
IC351
IC501
IC701
F-9
F-10
B-7
J-7
J-10
Q306
Q307
Q308
Q309
Q310
Q401
Q406
Q501
Q801
C-10
B-10
C-12
C-11
E-12
G-1
G-4
H-2
F-1
CDX-CA850/CA850X/CA860X
• Refer to page 27 for Waveforms.
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/4) — • Refer to page 42 for IC Block Diagrams.
IC B/D
*
*
*
*
*
*
_
:CA850/CA850X
:CA860X
IC B/D
(Page 36)
Note:
• Voltage is dc with respect to ground under
no-signal (detuned) condition.
no mark : FM
34
34
(Page 35)
CDX-CA850/CA850X/CA860X
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/4) — • Refer to page 43 for IC Block Diagrams.
IC B/D
US,Canadian model
IC B/D
AEP,UK model
(Page
34)
(Page 37)
Note:
• Voltage is dc with respect to ground under
no-signal (detuned) condition.
no mark : FM
35
35
CDX-CA850/CA850X/CA860X
• Refer to page 27 for Waveforms.
3-12. SCHEMATIC DIAGRAM — MAIN SECTION (3/4) — • Refer to page 42 for IC Block Diagrams.
(Page 34)
(Page 30)
(Page 37)
IC B/D
Note:
• Voltage is dc with respect to ground under
no-signal (detuned) condition.
no mark : FM
(
) : AM/MW/LW
<
> : CD PLAY
36
36
CDX-CA850/CA850X/CA860X
3-13. SCHEMATIC DIAGRAM — MAIN SECTION (4/4) — • Refer to page 27 for Waveforms.
(Page 35)
(Page
36)
(Page 39)
Note:
• Voltage is dc with respect to ground under
no-signal (detuned) condition.
no mark : FM
37
37
CDX-CA850/CA850X/CA860X
3-14. PRINTED WIRING BOARD — SUB (CD) SECTION —
(Page 33)
(Page 40)
38
38
CDX-CA850/CA850X/CA860X
3-15. SCHEMATIC DIAGRAM — SUB (CD) SECTION —
(Page 41)
(Page 37)
39
39
CDX-CA850/CA850X/CA860X
3-16. PRINTED WIRING BOARD — KEY SECTION —
• Semiconductor Location
Ref. No. Location
Ref. No.
(D900)
A-12
(IC903)
(D901)
A-11
(D902)
B-12
(LED900)
(D910)
B-3
LED910
D920
B-13
LED911
(D972)
A-9
LED912
(D974)
A-9
LED913
(IC901)
(IC902)
(
B-8
B-1
(Q903)
Location
B-3
B-1
B-12
B-2
B-12
B-2
(Page 38)
C-11
) : SIDE B
40
40
CDX-CA850/CA850X/CA860X
• Refer to page 27 for Waveforms.
3-17. SCHEMATIC DIAGRAM — KEY SECTION — • Refer to page 43 for IC Block Diagrams.
IC B/D
(Page 39)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
41
41
CDX-CA850/CA850X/CA860X
• IC BLOCK DIAGRAMS
IC1 CXA2596M
IC601 BA8270F
APC PD AMP
BUS ON 1
VCC
VEE
AGCVTH
+
–
2
VREF
1.25V
+
–
BATT 3
+
–
APC LD AMP
22 LD ON
3
B
4
CLK 4
VREF 5
DATA 6
21 HOLD SW
+
–
A
RESET
SWITCH
+
–
5
BATTERY
SWITCH
14 VCC
FWD
13
12
11
10
GND 7
RST
BUS ON
CLK IN
BU IN
2
CH2-CH4 OUTPUT
ON/OFF
MUTE2
35 MUTE2
VCC2
3
CH1 OUTPUT
ON/OFF
MUTE1
34 MUTE1
VL0–
4
33 VIN4
9 DATA IN
OUTPUT
CONTROL
VL0+
8 DATA OUT
VO4+
6
+
–
+
–
6
31 VIN4+
VO4–
7
VO3+
8
VIN1/VREF SW
18 RFTC
VC
VO3–
28 VREF-OUT (CH1)
9
–
+
17 RF I
8
RF EQ AMP
5V REG
+
–
VC
VEE
9
VO2+ 10
27 REG-OUT
LEVEL
SHIFT
+
–
+
–
F 10
16 RFO
ERROR AMP
FOCUS
VC
VC
26 REG-IN
VO2– 11
15 RFE
VO1+ 12
14 FE
VC
VC BUFFER
13 TE
VCC
VEE
+
–
VO1– 13
–
+
VC
–
+
VIN1–A 16
LVIN
CIN
SCOUT
VREF
MPX
VSSA
VDDA
AFIN
MAD
PSWN
20
19
18
17
16
15
14
13
12 11
VIN1+A 17
VIN1–B 18
PAUSE
DETECTOR
POWER SUPPLY
& RESET
CLOCKED
COMPARATOR
SIGNAL QUALITY
DECODER
4
5
CLOCK
RDS/RDBS
DECODER
4
CLOCK
INTERFACE
REGISTER
DATA
DATA
OSCILLATOR
& CLOCK
3
4
5
6
7
8
9
10
MRO
MPTH
TCON
OSCO
OSCI
VSSD
VDDD
DAVN
SDA
SCL
IIC BUS SLAVE
TRANSCEIVER
1 2
AMP-A
–
+
–
+
42
42
22 VIN2+
+
–
21 VIN2–
20 VIN2
19 VIN1 +B
AMP-B
57kHz
8th ORDER
BAND-PASS FILTER
TEST
CONTROL
23 VIN3
VIN1 15
IC201 SAA6588T
RDS/RDBS
DEMODULATOR
24 VIN3–
VCC1 14
VC
MULTI
PATH
DETECTOR
+
–
TRACKING
ERROR AMP
+
–
VC
VC 12
25 VIN3+
LEVEL
SHIFT
+
–
–
+
E 11
29 VIN1 (VREF)-SW
LEVEL
SHIFT
+
–
RF SUMMING AMP
VEE
30 VREF-IN
19 RF BOT
VC
7
VC
32 VIN4–
5
LEVEL
SHIFT
+
–
VEE
D
REV
20 AGCCONT
+
–
36 S-GND
INPUT
+
–
C
GND
1
VCC
VC
PD
RST 2
BUS ON
SWITCH
23 LC/PD
VEE
LD
24 VCC
VCC
+
–
+
–
1
+
–
HOLD
IC7 LA6556L-TE-L
CDX-CA850/CA850X/CA860X
OUTFL
OUTRL
OUTFR
OUTRR
OUTSW
SAOUT
33 32 31 30 29
28 27
26 25
24
23
ACINL
MIXINFL
MIXINRL
MIXINRR
MIXINFR
IC301 TDA7406T
MIXER
SOFT STEP
FADER
SOFT STEP
FADER
SOFT STEP
FADER
MONO
FADER
CREF
SUPPLY
22 VDD
21 SACLK
20 SCL
SUB
WOOFER
FILTER
19 SDA
OUTPUT SELECTOR
18 GND
SWIN 34
ACINR 35
17 ATT
ACOUTR 36
SWACOUT 37
AC OUTL 38
IIC-BUS
16 QUAL
QUAL.
HIGH PASS
A/D
7BAND
EQUALIZER
DIGITAL
CONTROL
CREF 39
HIGH OUT
PULSE
FORMER
S&H
SOFT STEP
VOLUME
25kHz
LP
AM/FM
NOISE
BLANKER
SOFT MUTE
LOUDNESS
BEEP
IN GAIN
+ AUTO
ZERO
MULTI
PATH
DETECTOR
DEMODULATOR
+STEREO ADJUST
+STEREO BLEND
SPECTRUM
ANALIZER
15 MP OUT
14 MP IN
PILOT
CANCELLATION
PIL, DET
13 LEVEL
PAUSE
PLL
MAIN SOURCE
SELECTOR
INPUT MULTIPLEXER
86kHz
LP
STD
IN GAIN
1 2 3 4 5
6 7 8
9
10
11
AM/MPX2
AMIF
CMPX
12 AUX1
PHONE
TIM
NAVI
40
41
42
43
44
TAPE R
FDR+
FDL–
FDL+
PAUSE
CDR
CDL
MDR
MDL
TAPEL
MIXING
SELECTOR
43
CDX-CA850/CA850X/CA860X
IC302, 303 NJM2160AV
16 CFL/R+
VCC 1
VREF
15 CFL/RINFL/R 2
SVRFL/R 3
14 GNDFL/R
INMFL/R 4
INMRL/R 5
13 OUTFL/R
SVRRL/R 6
11 GNDRL/R
12 OUTRL/R
INRR/L 7
10 CRL/RVREF
9 CRL/R+
VCC 8
IC902 RRX9000-0601
L IN
16
GND A
15
INPUT
SLAGE
V IN
14
GND
LNS C VCO NC
12 11 10 9
V AGC
13
320kHz
320kHz
/500kHz
NOISE
SUPPRESSION
PULSE
COUNTER
AGC
PULSE
FORMER
BANDGAP
REFERENCE
1 2
L IN GND
L
44
3
V STBY
4
VCC
5
NC
6
NC
7
VPO
8
NC
CDX-CA850/CA850X/CA860X
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories and packing materials and
hardware (# mark) list are given in
the last of this parts list.
Ver 1.1 2001. 04
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
45
CDX-CA850/CA850X/CA860X
Ver 1.1 2001. 04
4-1. CHASSIS SECTION
11
10
9
MG-383Z-121//Q
#1
16
#1
25
#1
#1
23
#5
#13
17
8
#6
12
#6
19
#1
#7
#6
#5
#5
14
#6
15
13
#1
TUX201
4
#4
18
3
17
2
1
F901
7
5
#1
6
#2
#3
20
#2
#3
22
#3
#2
24
#1
21
Ref. No.
Part No.
Description
1
2
* 3
4
5
X-3378-512-1
3-040-990-01
1-680-868-11
X-3376-699-1
3-030-909-01
PANEL ASSY, SUB
BUTTON (EJECT)
SUB (CD) BOARD
GEAR ASSY
DAMPER, OIL
6
7
* 8
9
3-713-786-51
X-3377-621-1
3-223-782-01
1-776-207-72
9
*
*
*
*
*
10
11
12
13
13
* 14
46
Remark
SCREW +P 2X3
LOCK ASSY
COVER
CORD (WITH CONNECTOR) (POWER)
(CA850X/CA860X)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(CA850)
3-041-012-01
3-227-287-01
3-223-783-21
3-223-780-01
3-223-780-21
BRACKET (CD)
SHEET, DUST PROTECTION
CHASSIS (BACK)
HEAT SINK (CA850)
HEAT SINK (CA850X/CA860X)
3-223-785-01 HEAT SINK (REG/D)
Ref. No.
*
*
*
*
15
16
16
16
17
* 18
19
Part No.
Description
3-040-998-01
A-3283-144-A
A-3283-145-A
A-3283-146-A
3-376-464-11
BRACKET (IC)
MAIN BOARD, COMPLETE (CA850)
MAIN BOARD, COMPLETE (CA860X)
MAIN BOARD, COMPLETE (CA850X)
SCREW (+PTT 2.6X6), GROUND POINT
Remark
* 20
* 21
22
3-045-878-01 PLATE (TU), GROUND
1-790-355-51 CORD (WITH CONNECTOR) (RCA)
(SUB OUT (MONO))
3-224-755-01 SHEET, INSULATING
3-223-781-01 CHASSIS
3-047-812-01 SCREW (LOCK)
* 23
24
25
F901
TUX201
3-045-857-01
1-792-195-11
3-046-626-01
1-532-877-11
A-3220-812-A
HEAT SINK (CD)
CABLE, FLEXIBLE FLAT (14 CORE)
SHEET, RADIATION
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER UNIT (TUX-020)
CDX-CA850/CA850X/CA860X
4-2. FRONT PANEL SECTION
not
supplied
#8
58
60
59
62
#8
54
58 not
53
supplied
56
57
not supplied
(KEY board)
55
56
LCD901
52
51
Ref. No.
*
*
*
*
51
52
53
54
55
56
* 57
Part No.
Description
X-3380-575-1
3-227-279-01
3-230-625-01
3-227-283-01
3-227-278-01
PANEL ASSY, FRONT
PLATE (LCD), GROUND
SHEET
SHEET (ILLUMINATOR)
PLATE (LCD), LIGHT GUIDE
1-694-780-11 CONDUCTIVE BOARD, CONNECTION
3-227-284-01 SHEET (REFLECTOR)
Remark
Ref. No.
58
59
60
60
60
Part No.
Description
3-031-319-01
X-3380-118-1
3-227-286-01
3-227-286-11
3-227-286-21
SPRING (BEARING)
PANEL ASSY, FRONT BACK
PLATE (FBP), ORNAMENTAL (CA850)
PLATE (FBP), ORNAMENTAL (CA850X)
PLATE (FBP), ORNAMENTAL (CA860X)
Remark
* 62
3-227-280-01 CASE (IR-T), SHIELD
LCD901 1-804-308-11 DISPLAY PANEL, LIQUID CRYSTAL
47
CDX-CA850/CA850X/CA860X
4-3. CD MECHANISM SECTION (1)
(MG-383Z-121//Q)
#9
102
#9
103
not supplied
109
not supplied
101
105
#11
106
C
107
M903
104
C
110
#10
108
#11
Ref. No.
Part No.
Description
* 101
* 102
103
* 104
105
1-659-836-11
A-3315-034-E
3-931-909-01
A-3326-231-A
3-338-737-01
DISC IN BOARD
CHASSIS (T) ASSY
SPRING (LR), TENSION
SERVO BOARD, COMPLETE
SCREW (2X3), +PS
* 106
1-659-837-11 LOAD BOARD
48
Remark
#11
#9
Ref. No.
Part No.
Description
107
* 108
109
110
M903
3-047-477-01
3-039-629-01
3-931-908-13
A-3315-040-A
A-3315-039-A
SPRING (RA2), TENSION COIL
BRACKET (MOTOR)
GUIDE (DISC)
ROLLER ASSY, ARM
MOTOR SUB ASSY, LD (LOADING)
Remark
CDX-CA850/CA850X/CA860X
4-4. CD MECHANISM SECTION (2)
(MG-383Z-121//Q)
154
151
156
157
157
158
D
166
160
167
162
155
155
153
165
164
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
X-3378-956-1
3-931-897-61
3-039-627-01
3-040-165-01
3-018-272-01
ARM ASSY, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WASHER
156
157
158
159
3-931-895-01
3-931-898-01
3-032-483-01
A-3307-471-C
SPRING (CH), TENSION
SPRING (FL), COMPRESSION
SPRING (KF1), TENSION
OVERALL ASSY, CHASSIS (M)
Remark
Ref. No.
Part No.
Description
160
161
162
163
164
3-220-180-01
3-931-881-01
3-931-882-02
3-007-537-11
3-032-484-01
SPRING (TR2), TENSION
LEVER (LOCK)
GEAR (MDL)
WHEEL (U), WORM
SPRING (KR1), TENSION
165
166
167
3-014-727-01 WHEEL (LW), WORM
3-039-626-01 LEVER (TR)
3-025-418-22 RING, LOADING
Remark
49
CDX-CA850/CA850X/CA860X
4-5. CD MECHANISM SECTION (3)
(MG-383Z-121//Q)
201
M901
207
202
M902
203
208
205
#12
206
209
210
#9
204
213
212
211
#9
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
* 205
X-3378-598-1
3-043-494-01
3-040-170-01
3-040-419-01
1-659-835-11
CHASSIS (OP) ASSY (including M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
LIMIT BOARD
206
207
50
3-338-737-01 SCREW (2X3), +PS
1-659-880-11 MOTOR FLEXIBLE BOARD
Remark
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
* 208
209
0 210
211
212
1-659-834-11
3-909-607-01
8-820-103-03
3-025-743-01
1-676-707-21
SUB BOARD
SCREW
PICK-UP, OPTICAL KSS-720A/K1RP
SPRING (FEED), LEAF
PICK-UP FLEXIBLE BOARD
213
M902
A-3315-306-A SHAFT (FEED) ASSY
A-3291-674-A MOTOR ASSY, SLED (SLED)
Remark
CDX-CA850/CA850X/CA860X
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
Ref. No.
Part No.
*
1-659-836-11 DISC IN BOARD
*************
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
Description
Remark
< SWITCH >
SW1
1-572-288-21 SWITCH, PUSH (DISC IN)
SW2
1-572-288-21 SWITCH, PUSH (SELF)
*************************************************************
Ref. No.
DISC IN
KEY
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Part No.
Description
Remark
D901
D902
D910
D920
D972
8-719-018-01
8-719-017-58
8-719-073-01
8-719-420-90
8-719-977-03
DIODE
DIODE
DIODE
DIODE
DIODE
D974
8-719-422-94 DIODE MA8091-L-TX
MA8220-TX
MA8068-TX
MA111-(K8).S0
MA8051-M-TX
MA8056-M-TX
< FERRITE BEAD >
KEY BOARD
**********
FB901
FB902
*
*
*
*
1-694-780-11
3-227-278-01
3-227-279-01
3-227-280-01
3-227-283-01
CONDUCTIVE BOARD, CONNECTION
PLATE (LCD), LIGHT GUIDE
PLATE (LCD), GROUND
CASE (IR-T), SHIELD
SHEET (ILLUMINATOR)
*
*
3-227-284-01 SHEET (REFLECTOR)
3-230-625-01 SHEET
1-414-235-22 INDUCTOR, FERRITE BEAD
1-414-235-22 INDUCTOR, FERRITE BEAD
< IC >
IC901
IC902
IC903
8-759-653-26 IC LC75878W
8-759-830-18 IC RRX9000-0601#1
8-759-830-17 IC RRX9000-0401R#01
< LIQUID CRYSTAL DISPLAY >
LCD901 1-804-308-11 DISPLAY PANEL, LIQUID CRYSTAL
< CAPACITOR >
C900
C901
C902
C903
C904
1-164-156-11
1-162-974-11
1-126-205-11
1-135-852-21
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.01uF
47uF
22uF
0.1uF
C905
C906
C907
C908
C910
1-135-852-21
1-162-974-11
1-164-388-11
1-115-156-11
1-164-156-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.01uF
270PF
1uF
0.1uF
C911
C912
C982
C983
C986
1-164-156-11
1-164-156-11
1-164-227-11
1-115-412-11
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.022uF
680PF
0.22uF
10%
5%
10%
25V
25V
25V
25V
16V
C990
C991
C992
C993
1-164-227-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
25V
16V
16V
16V
20%
20%
20%
5%
25V
50V
6.3V
6.3V
25V
6.3V
50V
50V
10V
25V
< DIODE >
LED900
LED910
LED911
LED912
LED913
8-719-083-14
8-719-076-58
8-719-076-58
8-719-076-58
8-719-076-58
LED
LED
LED
LED
LED
RRX9000-0501 (IR RECEIVE)
NSSW440-BRS (LCD BACK LIGHT)
NSSW440-BRS (LCD BACK LIGHT)
NSSW440-BRS (LCD BACK LIGHT)
NSSW440-BRS (LCD BACK LIGHT)
< SWITCH >
LSW921 1-762-619-21 SWITCH, KEYBOARD (WITH LED) (ON/OFF)
< TRANSISTOR >
Q903
8-729-904-75 TRANSISTOR DTD114EK-T-146
< RESISTOR >
R900
R901
R902
R903
R904
1-216-819-11
1-216-037-00
1-216-846-11
1-216-851-11
1-216-037-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
330
120K
330K
330
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/10W
R905
R910
R911
R912
R913
1-216-295-11
1-216-821-11
1-216-857-11
1-216-817-11
1-216-845-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
1K
1M
470
100K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
< CONNECTOR >
CN901
1-794-065-22 PLUG, CONNECTOR 14P
< DIODE >
D900
8-719-078-81 DIODE DF5A6.8FU(TE85R)
51
CDX-CA850/CA850X/CA860X
KEY
Ref. No.
LIMIT
LOAD
MAIN
Part No.
Description
Remark
Ref. No.
Part No.
R914
R915
R916
R917
R918
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
*
*
*
A-3283-144-A MAIN BOARD, COMPLETE (CA850)
A-3283-145-A MAIN BOARD, COMPLETE (CA860X)
A-3283-146-A MAIN BOARD, COMPLETE (CA850X)
*********************
Description
Remark
R919
R921
R922
R923
R924
1-216-797-11
1-216-029-00
1-216-029-00
1-216-029-00
1-216-029-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
150
150
150
150
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R971
R972
R973
R974
R979
1-216-029-00
1-216-027-00
1-216-029-00
1-216-027-00
1-216-041-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
120
150
120
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R980
R981
R982
R983
R984
1-216-029-00
1-216-029-00
1-216-029-00
1-216-857-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
150
1M
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R985
R986
R987
R988
R990
1-216-821-11
1-216-821-11
1-216-841-11
1-216-029-00
1-216-041-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
47K
150
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/10W
R991
R992
R993
R994
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
4.7K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1-790-355-53 CORD (WITH CONNECTOR) (RCA)
(SUB OUT (MONO))
3-040-998-01 BRACKET (IC)
3-223-780-01 HEAT SINK (CA850)
3-223-780-21 HEAT SINK (CA850X/CA860X)
3-223-783-21 CHASSIS (BACK)
*
*
*
*
3-223-785-01
7-685-646-79
7-685-790-01
7-685-793-09
7-685-794-09
*
HEAT SINK (REG/D)
SCREW +BVTP 3X8 TYPE2 N-S
SCREW +PTT 2.6X4 (S)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X10 (S)
7-685-797-09 SCREW +PTT 2.6X16 (S)
< CAPACITOR >
C102
C103
C106
C107
C108
1-127-573-11
1-124-259-11
1-164-156-11
1-164-156-11
1-126-936-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
4.7uF
0.1uF
0.1uF
3300uF
10%
20%
C201
C202
C203
C204
C205
1-162-918-11
1-162-968-11
1-124-589-11
1-164-156-11
1-126-154-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
18PF
0.0047uF
47uF
0.1uF
47uF
5%
10%
20%
C206
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C207
1-164-156-11 CERAMIC CHIP
0.1uF
C208
1-162-920-11 CERAMIC CHIP
27PF
5%
C209
1-162-920-11 CERAMIC CHIP
27PF
5%
C210
1-164-315-11 CERAMIC CHIP
470PF
5%
C211
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C212
1-162-966-11 CERAMIC CHIP
0.0022uF 10%
C213
1-164-739-11 CERAMIC CHIP
560PF
C214
1-135-834-11 CERAMIC CHIP
2.2uF
C215
1-162-959-11 CERAMIC CHIP
330PF
C216
1-164-156-11 CERAMIC CHIP
0.1uF
C217
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C218
1-162-964-11 CERAMIC CHIP
0.001uF
10%
20%
20%
< VIBRATOR >
X910
1-781-646-21 VIBRATOR, CERAMIC (4MHz)
*************************************************************
*
1-659-835-11 LIMIT BOARD
***********
< SWITCH >
SW3
1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
*
1-659-837-11 LOAD BOARD
*********
< SWITCH >
SW4
1-572-288-21 SWITCH, PUSH (DOWN)
*************************************************************
52
5%
5%
16V
16V
25V
25V
16V
50V
50V
16V
25V
6.3V
50V
(CA850)
25V
(CA850)
50V
(CA850)
50V
(CA850)
50V
(CA850)
16V
(CA850)
50V
(CA850)
50V
(CA850)
6.3V
(CA850)
50V
(CA850)
25V
(CA850)
50V
(CA850)
50V
(CA850)
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Part No.
Description
Remark
C219
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C220
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C221
1-164-315-11 CERAMIC CHIP
470PF
5%
C222
1-162-915-11 CERAMIC CHIP
10PF
0.5PF
C223
1-125-891-11 CERAMIC CHIP
0.47uF
10%
50V
(CA850)
16V
(CA850)
50V
(CA850)
50V
(CA850)
10V
(CA850)
C333
1-162-919-11 CERAMIC CHIP
22PF
5%
C334
1-124-584-00 ELECT
100uF
20%
C335
C336
1-124-779-00 ELECT CHIP
1-162-927-11 CERAMIC CHIP
10uF
100PF
20%
5%
25V
(CA860X)
50V
(CA860X)
10V
(CA860X)
16V
50V
C337
C338
C339
C340
C341
1-124-779-00
1-162-927-11
1-124-779-00
1-162-927-11
1-124-779-00
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
10uF
100PF
10uF
100PF
10uF
20%
5%
20%
5%
20%
16V
50V
16V
50V
16V
C342
C343
C344
C345
C346
1-162-927-11
1-126-157-11
1-104-942-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
100PF
10uF
1uF
100PF
100PF
5%
20%
20%
5%
5%
50V
16V
50V
50V
50V
C347
C349
1-124-589-11 ELECT
1-126-157-11 ELECT
47uF
10uF
20%
20%
C350
1-115-467-11 CERAMIC CHIP
0.22uF
C350
1-125-891-11 CERAMIC CHIP
0.47uF
C351
1-115-467-11 CERAMIC CHIP
0.22uF
C351
1-125-891-11 CERAMIC CHIP
0.47uF
C352
1-115-467-11 CERAMIC CHIP
0.22uF
C352
1-125-891-11 CERAMIC CHIP
0.47uF
C353
1-115-467-11 CERAMIC CHIP
0.22uF
C353
1-125-891-11 CERAMIC CHIP
0.47uF
C354
1-165-176-11 CERAMIC CHIP
0.047uF
C356
C357
C358
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
1-124-589-11 ELECT
100PF
100PF
47uF
50V
(CA860X)
16V
(CA860X)
25V
(CA860X)
10V
(CA860X)
50V
(CA860X)
C358
1-126-157-11 ELECT
10uF
C359
C360
C364
C365
1-164-156-11
1-164-156-11
1-164-156-11
1-125-837-11
0.1uF
0.1uF
0.1uF
1uF
C365
1-162-964-11 CERAMIC CHIP
0.001uF
16V
(CA860X)
10V
16V
(CA860X)
10V
(CA860X)
50V
(CA860X)
C368
1-164-156-11 CERAMIC CHIP
0.1uF
C373
1-162-927-11 CERAMIC CHIP
C373
1-162-966-11 CERAMIC CHIP
C374
1-162-927-11 CERAMIC CHIP
C374
1-162-966-11 CERAMIC CHIP
C375
1-162-927-11 CERAMIC CHIP
10%
C225
1-126-785-11 ELECT
47uF
20%
C226
C227
C228
1-164-156-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
C229
C302
C303
C304
C305
1-125-837-11
1-162-970-11
1-125-891-11
1-162-968-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
0.47uF
0.0047uF
1uF
10%
10%
10%
10%
10%
6.3V
25V
10V
50V
6.3V
C306
C307
C308
C309
C310
1-165-176-11
1-162-970-11
1-126-193-11
1-126-193-11
1-126-193-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
0.047uF
0.01uF
1uF
1uF
1uF
10%
10%
20%
20%
20%
16V
25V
50V
50V
50V
C311
C312
C313
C314
C315
1-104-942-11
1-136-154-00
1-162-965-11
1-136-154-00
1-162-965-11
ELECT
FILM
CERAMIC CHIP
FILM
CERAMIC CHIP
1uF
0.012uF
0.0015uF
0.012uF
0.0015uF
20%
5%
10%
5%
10%
50V
50V
50V
50V
50V
C316
C317
1-126-157-11 ELECT
1-127-573-11 CERAMIC CHIP
10uF
1uF
20%
10%
C318
1-164-156-11 CERAMIC CHIP
0.1uF
C319
1-126-157-11 ELECT
10uF
20%
C320
1-124-584-00 ELECT
100uF
20%
16V
16V
(CA860X)
25V
(CA860X)
16V
(CA860X)
10V
(CA860X)
C321
1-162-919-11 CERAMIC CHIP
22PF
5%
C322
1-127-573-11 CERAMIC CHIP
1uF
10%
C323
1-164-156-11 CERAMIC CHIP
0.1uF
C324
1-124-584-00 ELECT
100uF
20%
C325
1-162-919-11 CERAMIC CHIP
22PF
5%
C326
1-127-573-11 CERAMIC CHIP
1uF
10%
C327
C328
1-126-785-11 ELECT
1-126-157-11 ELECT
47uF
10uF
20%
20%
C329
1-124-584-00 ELECT
100uF
20%
C330
1-162-919-11 CERAMIC CHIP
22PF
5%
10%
Remark
0.1uF
0.047uF
1uF
Description
1-164-156-11 CERAMIC CHIP
1-165-176-11 CERAMIC CHIP
1-127-573-11 CERAMIC CHIP
Part No.
C332
C224
C331
Ref. No.
16V
(CA850)
10V
(CA850)
25V
25V
25V
(CA850)
16V
(CA860X)
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
16V
16V
(CA860X)
10%
10V
(CA860X)
10%
10V
(CA850/CA850X)
10%
10V
(CA860X)
10%
10V
(CA850/CA850X)
10%
10V
(CA860X)
10%
10V
(CA850/CA850X)
10%
10V
(CA860X)
10%
10V
(CA850/CA850X)
10%
16V
(CA860X)
5%
50V
5%
50V
20%
16V
(CA860X)
20%
16V
(CA850/CA850X)
25V
25V
25V
10%
6.3V
(CA860X)
10%
50V
(CA850/CA850X)
25V
(CA860X)
100PF
5%
50V
(CA860X)
0.0022uF 10%
50V
(CA850/CA850X)
100PF
5%
50V
(CA860X)
0.0022uF 10%
50V
(CA850/CA850X)
100PF
5%
50V
(CA860X)
53
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Part No.
Description
C375
1-162-966-11 CERAMIC CHIP
C376
1-162-927-11 CERAMIC CHIP
C376
1-162-966-11 CERAMIC CHIP
C377
1-162-927-11 CERAMIC CHIP
C377
1-162-966-11 CERAMIC CHIP
Remark
0.0022uF 10%
50V
(CA850/CA850X)
100PF
5%
50V
(CA860X)
0.0022uF 10%
50V
(CA850/CA850X)
100PF
5%
50V
(CA860X)
0.0022uF 10%
50V
(CA850/CA850X)
C378
C379
1-164-227-11 CERAMIC CHIP
1-125-837-11 CERAMIC CHIP
0.022uF
1uF
10%
10%
C380
1-125-837-11 CERAMIC CHIP
1uF
10%
C381
1-125-837-11 CERAMIC CHIP
1uF
10%
C382
1-125-837-11 CERAMIC CHIP
1uF
10%
C383
1-164-156-11 CERAMIC CHIP
0.1uF
C384
1-164-156-11 CERAMIC CHIP
0.1uF
C385
C386
1-125-889-11 CERAMIC CHIP
1-162-919-11 CERAMIC CHIP
2.2uF
22PF
C386
1-162-964-11 CERAMIC CHIP
0.001uF
25V
(CA860X)
25V
(CA860X)
10%
10V
5%
50V
(CA860X)
10%
50V
(CA850/CA850X)
C387
1-162-919-11 CERAMIC CHIP
22PF
C387
1-162-964-11 CERAMIC CHIP
0.001uF
C388
1-162-919-11 CERAMIC CHIP
22PF
C388
1-162-964-11 CERAMIC CHIP
0.001uF
C389
1-162-919-11 CERAMIC CHIP
22PF
C389
1-162-964-11 CERAMIC CHIP
0.001uF
C390
1-162-964-11 CERAMIC CHIP
0.001uF
C391
1-125-837-11 CERAMIC CHIP
1uF
C392
1-164-156-11 CERAMIC CHIP
0.1uF
C393
1-127-715-11 CERAMIC CHIP
0.22uF
C394
C401
C402
C403
C404
1-127-715-11
1-107-826-11
1-162-961-11
1-126-154-11
1-165-128-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.22uF
0.1uF
330PF
47uF
0.22uF
10%
10%
10%
20%
16V
16V
50V
6.3V
16V
C405
C406
C407
C408
C410
1-126-154-11
1-126-154-11
1-126-176-11
1-128-057-11
1-107-826-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
47uF
47uF
220uF
330uF
0.1uF
20%
20%
20%
20%
10%
6.3V
6.3V
10V
6.3V
16V
C411
1-162-923-11 CERAMIC CHIP
47PF
5%
C412
1-162-923-11 CERAMIC CHIP
47PF
5%
C413
C414
C415
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
0.001uF
0.001uF
0.001uF
10%
10%
10%
50V
(CA850)
50V
(CA850)
50V
50V
50V
54
25V
6.3V
(CA860X)
6.3V
(CA860X)
6.3V
(CA860X)
6.3V
(CA860X)
5%
50V
(CA860X)
10%
50V
(CA850/CA850X)
5%
50V
(CA860X)
10%
50V
(CA850/CA850X)
5%
50V
(CA860X)
10%
50V
(CA850/CA850X)
10%
50V
(CA850)
10%
6.3V
(CA860X)
25V
(CA860X)
10%
16V
Ref. No.
Part No.
Description
C416
C501
C503
C504
C505
1-162-964-11
1-164-156-11
1-164-156-11
1-164-156-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
Remark
C505
1-165-176-11 CERAMIC CHIP
0.047uF
C506
C507
C508
C509
1-164-156-11
1-164-315-11
1-164-230-11
1-162-921-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
220PF
33PF
C510
C511
C512
C513
C514
1-162-917-11
1-162-964-11
1-135-834-11
1-164-156-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
15PF
0.001uF
2.2uF
0.1uF
100PF
C515
C516
C518
C519
C520
1-162-974-11
1-162-974-11
1-164-156-11
1-107-877-11
1-125-701-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
DOUBLE LAYERS
0.01uF
0.01uF
0.1uF
1000uF
0.047F
C521
C522
C601
C602
C603
1-124-584-00
1-164-156-11
1-162-974-11
1-125-837-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.01uF
1uF
100PF
20%
C604
C701
C702
C703
C704
1-104-653-11
1-162-964-11
1-164-156-11
1-164-156-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
0.001uF
0.1uF
0.1uF
0.1uF
20%
10%
C705
C706
C707
C708
C709
1-164-156-11
1-164-156-11
1-107-826-11
1-126-205-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
47uF
0.1uF
10%
20%
10%
25V
25V
16V
6.3V
16V
C710
C711
C712
C713
C714
1-162-974-11
1-162-970-11
1-126-401-21
1-162-970-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
1uF
0.01uF
0.001uF
10%
20%
10%
10%
50V
25V
50V
25V
50V
C715
C716
C717
C718
C722
1-164-156-11
1-164-156-11
1-162-927-11
1-162-927-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
100PF
100PF
0.01uF
C723
C801
C802
C803
C804
1-162-974-11
1-162-974-11
1-162-974-11
1-128-526-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
100uF
0.47uF
20%
10%
C805
1-124-589-11 ELECT
47uF
20%
C806
1-126-154-11 ELECT
47uF
20%
0.001uF 10%
0.1uF
0.1uF
0.1uF
0.0047uF 10%
< CONNECTOR >
CN101
* CN301
1-774-701-11 PIN, CONNECTOR 16P
1-564-506-11 PLUG, CONNECTOR 3P
50V
25V
25V
25V
50V
(CA850)
10%
16V
(CA850X/CA860X)
25V
5%
50V
5%
50V
5%
50V
5%
10%
5%
20%
10%
5%
5%
5%
50V
50V
6.3V
25V
50V
(CA850)
50V
50V
25V
10V
5.5V
10V
25V
50V
6.3V
50V
16V
50V
25V
25V
25V
25V
25V
50V
50V
50V
50V
50V
50V
10V
10V
16V
(CA860X)
6.3V
(CA860X)
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
CN401
CN601
CN701
Part No.
Description
Remark
1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P
1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)
1-784-456-11 CONNECTOR, FFC/FPC 14P
Ref. No.
FB403
FB501
FB701
Part No.
1-815-185-11 JACK (ANTENNA)
1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,AUDIO OUT)
< DIODE >
D101
D102
D105
D106
D107
8-719-049-38
8-719-017-58
8-719-073-01
8-719-053-18
8-719-053-18
DIODE
DIODE
DIODE
DIODE
DIODE
1N5404TU
MA8068
MA111-(K8).S0
1SR154-400TE-25
1SR154-400TE-25
D110
D202
D203
D204
D301
8-719-975-40
8-719-073-01
8-719-422-41
8-719-800-76
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
RB411D-T146 (CA860X)
MA111-(K8).S0
MA8051-L-TX
1SS226 (CA850)
11ES2
D302
D303
D304
D305
D306
8-719-200-82
8-719-200-82
8-719-053-18
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
1SR154-400TE-25
11ES2
11ES2
D307
D308
D310
D311
D401
8-719-200-82
8-719-200-82
8-719-801-78
8-719-073-01
8-719-017-67
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
1SS184
MA111-(K8).S0
MA8068-H
D402
D501
D503
D504
D505
8-719-422-64
8-719-801-78
8-719-977-03
8-719-073-01
8-719-422-41
DIODE
DIODE
DIODE
DIODE
DIODE
MA8062-M
1SS184
DTZ5.6B
MA111-(K8).S0
MA8051-L-TX (CA850)
D601
D603
D604
D605
D606
8-719-073-01
8-719-017-94
8-719-420-51
8-719-018-01
8-719-018-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-(K8).S0
MA8180
MA729
MA8220-TX
MA8220-TX
D607
D608
D609
D610
D653
8-719-801-78
8-719-073-01
8-719-422-64
8-719-073-01
8-719-820-05
DIODE
DIODE
DIODE
DIODE
DIODE
1SS184
MA111-(K8).S0
MA8062-M
MA111-(K8).S0
1SS181
D703
D707
D708
D715
D801
8-719-018-01
8-719-017-58
8-719-018-01
8-719-801-78
8-719-420-14
DIODE
DIODE
DIODE
DIODE
DIODE
MA8220-TX
MA8068
MA8220-TX
1SS184
MA8082-M
D802
8-719-420-92 DIODE MA8051-M-TX
Remark
< IC >
< JACK >
CN201
CN302
Description
1-414-235-22 INDUCTOR, FERRITE BEAD (CA850)
1-414-235-22 INDUCTOR, FERRITE BEAD
1-414-235-22 INDUCTOR, FERRITE BEAD
IC201
IC202
IC301
IC302
IC303
8-759-492-59
8-759-909-71
8-759-827-13
8-759-826-90
8-759-826-90
IC
IC
IC
IC
IC
SAA6588T/V2-118 (CA850)
BA4558F-E2 (CA850)
TDA7406T
NJM2160AV-TE2 (CA860X)
NJM2160AV-TE2 (CA860X)
IC304
IC305
IC308
IC309
IC310
8-759-832-29
8-759-832-29
8-759-100-96
8-759-100-96
8-759-198-34
IC
IC
IC
IC
IC
NJM4580M-(TE2)
NJM4580M-(TE2)
uPC4558G2 (CA860X)
uPC4558G2 (CA860X)
TA75S558F(TE85R) (CA860X)
IC351
IC351
IC501
IC501
8-759-660-96
8-759-827-14
6-800-243-01
8-759-837-48
IC
IC
IC
IC
IC502
TDA7560 (CA860X)
TA8268AH (CA850/CA850X)
MB90574BPMT-G-335-BND (CA850)
MB90574BPMT-G-323-BND
(CA850X/CA860X)
8-759-828-22 IC XC61CN4102MR
IC601
IC701
IC702
IC801
8-759-449-89
6-800-141-01
8-759-277-63
8-759-460-80
IC
IC
IC
IC
BA8270F-E2
HD6432355A37F
TC7W14FU(TE12R)
BA10FP-E2 (CA860X)
< JACK >
J651
1-566-822-41 JACK (REMOTE IN) (CA850)
< COIL >
L101
L201
L202
1-419-476-11 COIL, CHOKE
1-216-864-11 SHORT
1-216-296-11 SHORT
250uH
0
0
< TRANSISTOR >
< FERRITE BEAD >
FB201
FB301
FB401
FB402
FB403
1-414-235-22
1-414-235-22
1-414-235-22
1-414-235-22
1-414-234-22
INDUCTOR, FERRITE BEAD (CA850)
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD (CA850X/CA860X)
Q101
Q102
Q103
Q104
Q105
8-729-120-28
8-729-120-28
8-729-120-28
8-729-049-13
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
UPA1853GR-9JG-E1
UN2211
Q106
Q201
Q202
Q204
Q205
8-729-421-22
8-729-106-60
8-729-421-22
8-729-120-28
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211
2SB1115A-YQ
UN2211
2SC1623-L5L6 (CA850)
UN2211 (CA850)
Q207
Q303
Q304
Q306
Q306
8-729-920-85
8-729-421-22
8-729-424-08
8-729-021-95
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-QR
UN2211
UN2111
RN1441-A(TE85L) (CA860X)
DTC314TKH04 (CA850/CA850X)
Q307
Q307
Q308
Q308
Q309
8-729-021-95
8-729-920-21
8-729-021-95
8-729-920-21
8-729-021-95
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1441-A(TE85L) (CA860X)
DTC314TKH04 (CA850/CA850X)
RN1441-A(TE85L) (CA860X)
DTC314TKH04 (CA850/CA850X)
RN1441-A(TE85L) (CA860X)
Q309
8-729-920-21 TRANSISTOR DTC314TKH04 (CA850/CA850X)
55
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Part No.
Description
Q310
Q401
Q402
Q403
Q405
8-729-920-21
8-729-021-82
8-729-421-22
8-729-424-08
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TKH04
2SD2396K
UN2211
UN2111
UN2211
Remark
R210
1-216-853-11 METAL CHIP
470K
5%
R211
1-216-797-11 METAL CHIP
10
5%
R212
1-216-825-11 METAL CHIP
2.2K
5%
Q406
Q407
Q501
Q602
Q603
8-729-920-85
8-729-424-08
8-729-040-17
8-729-421-22
8-729-424-18
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-QR
UN2111-TX
2SD2164-K
UN2211
UN2113
R213
1-216-825-11 METAL CHIP
2.2K
5%
R214
1-216-857-11 METAL CHIP
1M
5%
R215
1-216-809-11 METAL CHIP
100
5%
Q701
Q702
Q703
Q705
Q706
8-729-424-08
8-729-106-60
8-729-120-28
8-729-026-49
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2111
2SB1115A-YQ
2SC1623-L5L6
2SA1037AK-T146-R
2SC1623-L5L6
R216
1-216-833-11 METAL CHIP
10K
5%
R217
1-216-833-11 METAL CHIP
10K
5%
R218
1-216-809-11 METAL CHIP
100
5%
Q801
Q802
Q803
8-729-024-95 TRANSISTOR 2SB1565EF
8-729-120-28 TRANSISTOR 2SC1623-L5L6
8-729-120-28 TRANSISTOR 2SC1623-L5L6
R219
1-216-845-11 METAL CHIP
100K
5%
< RESISTOR >
R220
1-216-825-11 METAL CHIP
2.2K
5%
R221
R222
1-216-841-11 METAL CHIP
1-216-809-11 METAL CHIP
47K
100
R222
R223
1-216-864-11 SHORT
1-216-809-11 METAL CHIP
0
100
R223
R301
R302
R303
R304
1-216-864-11
1-216-841-11
1-216-845-11
1-216-833-11
1-216-833-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
47K
100K
10K
10K
(CA850X/CA860X)
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
R305
R306
R307
R308
R309
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
R310
R311
1-216-833-11 METAL CHIP
1-216-845-11 METAL CHIP
10K
100K
5%
5%
R312
R313
R314
1-216-833-11 METAL CHIP
1-216-864-11 SHORT
1-216-833-11 METAL CHIP
10K
0
10K
1/16W
1/16W
(CA860X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
R315
1-216-797-11 METAL CHIP
10
5%
R316
1-216-817-11 METAL CHIP
470
5%
R317
1-216-839-11 METAL CHIP
33K
5%
R318
1-216-837-11 METAL CHIP
22K
5%
R319
1-216-837-11 METAL CHIP
22K
5%
R320
1-216-817-11 METAL CHIP
470
5%
R101
R102
R103
R104
R105
1-216-821-11
1-216-073-00
1-216-073-00
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
10K
1K
47K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/16W
1/16W
R106
R107
R108
R109
R110
1-216-829-11
1-216-841-11
1-216-829-11
1-216-829-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
4.7K
4.7K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R111
R113
R114
R115
R116
1-216-837-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R117
R118
R125
R130
R131
1-216-833-11
1-216-833-11
1-216-841-11
1-216-073-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
47K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/10W
R201
R202
R203
R204
R205
1-216-797-11
1-216-831-11
1-216-833-11
1-216-829-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
6.8K
10K
4.7K
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R206
1-216-817-11 METAL CHIP
470
5%
R207
1-216-797-11 METAL CHIP
10
5%
R208
1-216-832-11 METAL CHIP
8.2K
5%
R209
1-216-821-11 METAL CHIP
1K
5%
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
56
Ref. No.
Part No.
Description
Remark
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
1/16W
(CA850)
5%
1/16W
5%
1/16W
(CA850)
(CA850X/CA860X)
5%
1/16W
(CA850)
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Part No.
Description
Remark
R321
1-216-797-11 METAL CHIP
10
5%
R322
1-216-839-11 METAL CHIP
33K
5%
R323
1-216-797-11 METAL CHIP
10
5%
R324
1-216-817-11 METAL CHIP
470
5%
R325
1-216-839-11 METAL CHIP
33K
5%
R326
1-216-837-11 METAL CHIP
22K
5%
R327
1-216-837-11 METAL CHIP
22K
5%
R328
1-216-817-11 METAL CHIP
470
5%
R329
1-216-797-11 METAL CHIP
10
5%
R330
1-216-839-11 METAL CHIP
33K
5%
R331
R332
R333
R334
R335
1-216-821-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-813-11
1K
10K
10K
1K
220
5%
5%
5%
5%
5%
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R335
R336
1-216-864-11 SHORT
1-216-841-11 METAL CHIP
0
47K
R337
1-216-813-11 METAL CHIP
220
R337
R338
1-216-864-11 SHORT
1-216-841-11 METAL CHIP
0
47K
R339
1-216-813-11 METAL CHIP
220
R339
R340
1-216-864-11 SHORT
1-216-841-11 METAL CHIP
0
47K
R341
1-216-813-11 METAL CHIP
220
R341
1-216-864-11 SHORT
0
R342
1-216-841-11 METAL CHIP
47K
R343
R344
R345
R346
1-216-864-11
1-216-841-11
1-216-864-11
1-216-864-11
SHORT
METAL CHIP
SHORT
SHORT
0
47K
0
0
R347
R348
R357
R358
R359
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
R360
R364
R365
1-216-864-11 SHORT
1-216-829-11 METAL CHIP
1-216-864-11 SHORT
0
4.7K
0
Ref. No.
Part No.
Description
Remark
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
R368
R369
R370
1-216-805-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-833-11 METAL CHIP
47
1K
10K
R370
1-216-841-11 METAL CHIP
47K
R372
1-216-801-11 METAL CHIP
22
R372
1-216-831-11 METAL CHIP
6.8K
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
R373
R375
R376
R377
1-216-833-11
1-216-813-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
220
220
220
R378
R379
R380
R381
R382
1-216-813-11
1-216-813-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT
SHORT
SHORT
220
220
0
0
0
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
(CA860X)
R383
1-216-835-11 METAL CHIP
15K
5%
R383
R384
1-216-864-11 SHORT
1-216-835-11 METAL CHIP
0
15K
R384
R385
1-216-864-11 SHORT
1-216-835-11 METAL CHIP
0
15K
R385
R386
1-216-864-11 SHORT
1-216-835-11 METAL CHIP
0
15K
R386
R387
1-216-864-11 SHORT
1-216-833-11 METAL CHIP
0
10K
R388
1-216-825-11 METAL CHIP
2.2K
R389
1-216-833-11 METAL CHIP
10K
5%
R390
1-216-825-11 METAL CHIP
2.2K
5%
R391
1-216-833-11 METAL CHIP
10K
5%
R392
1-216-825-11 METAL CHIP
2.2K
5%
R393
1-216-833-11 METAL CHIP
10K
5%
R394
1-216-825-11 METAL CHIP
2.2K
5%
R395
1-216-845-11 METAL CHIP
100K
5%
R396
1-216-845-11 METAL CHIP
100K
5%
R397
1-216-845-11 METAL CHIP
100K
5%
R398
1-216-845-11 METAL CHIP
100K
5%
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
(CA850/CA850X)
5%
1/16W
(CA850/CA850X)
5%
5%
5%
1/16W
1/16W
1/16W
(CA860X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
(CA860X)
5%
1/16W
(CA850/CA850X)
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
1/16W
1/16W
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA860X)
(CA850/CA850X)
5%
1/16W
(CA860X)
5%
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
57
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Part No.
Description
Remark
R399
1-216-837-11 METAL CHIP
22K
5%
R400
1-216-833-11 METAL CHIP
10K
5%
R401
R402
R403
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
2.2K
2.2K
2.2K
5%
5%
5%
R405
R406
R407
R408
R410
1-216-864-11
1-216-793-11
1-216-805-11
1-216-797-11
1-216-801-11
0
4.7
47
10
22
5%
5%
5%
5%
R417
R422
1-216-825-11 METAL CHIP
1-216-839-11 METAL CHIP
2.2K
33K
5%
5%
R423
1-216-839-11 METAL CHIP
33K
5%
R424
1-216-839-11 METAL CHIP
33K
5%
R425
1-216-839-11 METAL CHIP
33K
5%
R426
R427
R428
R429
R430
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
R501
R503
SHORT
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
R533
R534
R535
R536
R539
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-845-11
SHORT
SHORT
SHORT
SHORT
METAL CHIP
0
0
0
0
100K
Remark
5%
1/16W
R540
R541
R601
R604
R605
1-216-864-11
1-216-821-11
1-216-809-11
1-216-821-11
1-216-809-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
1K
100
1K
100
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R607
R652
R653
R654
1-216-835-11
1-218-871-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
10K
100
100
5%
0.5%
5%
5%
R702
1-216-809-11 METAL CHIP
100
5%
1/16W
1/16W
1/16W
1/16W
(CA850)
1/16W
R703
R704
R705
R706
R707
1-216-845-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-845-11
METAL CHIP
SHORT
SHORT
METAL CHIP
METAL CHIP
100K
0
0
100
100K
5%
1/16W
5%
5%
1/16W
1/16W
R708
R709
R711
R712
R713
1-216-845-11
1-216-845-11
1-216-037-00
1-216-829-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
330
4.7K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R714
R715
R716
R717
R718
1-216-813-11
1-216-813-11
1-216-813-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1K
1K
1K
1K
0
5%
5%
5%
5%
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
5%
5%
R504
R505
R506
1-216-845-11 METAL CHIP
1-216-864-11 SHORT
1-216-837-11 METAL CHIP
100K
0
22K
5%
5%
R507
R508
R509
R510
R511
1-216-845-11
1-216-833-11
1-216-833-11
1-216-841-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
47K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R719
R720
R721
R724
R728
1-216-821-11
1-218-871-11
1-218-871-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
10K
100K
100K
5%
0.5%
0.5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R512
R513
R514
R515
R516
1-216-845-11
1-216-829-11
1-216-813-11
1-216-845-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
100K
4.7K
220
100K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R729
R731
R732
R733
R734
1-216-821-11
1-216-813-11
1-216-821-11
1-216-037-00
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
1K
330
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/16W
R517
R520
R521
R522
R523
1-216-864-11
1-216-864-11
1-216-809-11
1-216-845-11
1-216-845-11
SHORT
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
0
0
100
100K
100K
5%
5%
5%
1/16W
1/16W
1/16W
R735
R736
R737
R738
R739
1-216-821-11
1-216-821-11
1-216-829-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
4.7K
4.7K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R524
R525
R526
R527
R530
1-216-845-11
1-216-853-11
1-216-835-11
1-216-793-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
100K
470K
15K
4.7
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R740
R741
R742
R743
R744
1-216-829-11
1-216-037-00
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
330
10K
10K
1K
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R531
R532
1-216-821-11 METAL CHIP
1-216-864-11 SHORT
1K
0
5%
1/16W
R745
1-216-005-00 METAL CHIP
15
5%
1/10W
58
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
1/16W
(CA860X)
1/16W
(CA860X)
1/16W
1/16W
1/16W
1/16W
1/16W
(CA860X)
1/16W
(CA850)
1/16W
(CA860X)
CDX-CA850/CA850X/CA860X
MAIN
Ref. No.
Remark
Part No.
Description
Part No.
Description
R746
R747
R748
R749
R750
1-216-005-00
1-216-005-00
1-216-005-00
1-216-005-00
1-216-005-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15
15
15
15
15
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C304
C305
C306
C307
C308
1-164-227-11
1-162-965-11
1-162-965-11
1-162-962-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.0015uF
0.0015uF
470PF
470PF
10%
10%
10%
10%
10%
25V
50V
50V
50V
50V
R801
R802
R803
R804
R805
1-216-829-11
1-216-833-11
1-216-821-11
1-216-817-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
1K
470
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C309
C310
C311
C312
C501
1-164-227-11
1-125-838-11
1-164-677-11
1-164-360-11
1-126-391-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.022uF
2.2uF
0.033uF
0.1uF
47uF
10%
10%
10%
20%
25V
6.3V
16V
16V
6.3V
R806
R813
1-216-864-11 SHORT
1-216-815-11 METAL CHIP
0
330
5%
1/16W
(CA860X)
C502
C504
C505
C506
C507
1-162-965-11
1-162-967-11
1-165-176-11
1-107-823-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0033uF
0.047uF
0.47uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
16V
16V
16V
C508
C509
C510
C511
C512
1-164-230-11
1-164-360-11
1-164-217-11
1-164-217-11
1-162-963-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
0.1uF
150PF
150PF
680PF
5%
50V
16V
50V
50V
50V
C513
C514
C515
C516
C517
1-162-963-11
1-126-391-11
1-164-360-11
1-162-974-11
1-164-360-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
47uF
0.1uF
0.01uF
0.1uF
10%
20%
C518
C519
C520
C521
C522
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
C550
C553
C554
1-164-360-11 CERAMIC CHIP
1-164-360-11 CERAMIC CHIP
1-164-360-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
16V
16V
16V
< SWITCH >
S101
S102
1-692-431-21 SWITCH, TACTILE (RESET)
1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET)
< THERMISTOR (POSITIVE) >
TH101
TH102
TH601
1-810-940-11 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
1-801-792-21 THERMISTOR, POSITIVE
< TUNER >
Ref. No.
SERVO
Remark
5%
5%
10%
50V
6.3V
16V
50V
16V
TUX201 A-3220-812-A TUNER UNIT (TUX-020)
< VIBRATOR >
X201
1-767-853-21 VIBRATOR, CRYSTAL (4.332MHz) (CA850)
X501
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X502
1-767-833-21 VIBRATOR, CERAMIC (3.68MHz)
X701
1-781-822-21 VIBRATOR, CERAMIC (18.432MHz)
*************************************************************
A-3326-231-A SERVO BOARD, COMPLETE
**********************
*
< CONNECTOR >
< CAPACITOR >
C101
C103
C104
C106
C107
1-115-156-11
1-104-609-11
1-115-156-11
1-107-826-11
1-125-837-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
100uF
1uF
0.1uF
1uF
C108
C109
C111
C115
C116
1-162-974-11
1-162-917-11
1-115-156-11
1-164-733-11
1-165-128-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
15PF
1uF
820PF
0.22uF
C117
C118
C127
C301
C302
1-164-733-11
1-164-360-11
1-104-851-11
1-126-393-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
ELECT CHIP
CERAMIC CHIP
820PF
0.1uF
10uF
33uF
0.1uF
10%
C303
1-164-227-11 CERAMIC CHIP
0.022uF
10%
20%
10%
10%
5%
10%
20%
20%
10V
4V
10V
16V
6.3V
50V
50V
10V
50V
16V
50V
16V
10V
10V
16V
25V
CN1
CN2
CN3
1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-770-347-21 CONNECTOR, FPC 6P
< JUMPER RESISTOR >
FB101
FB102
FB503
1-216-295-11 SHORT
1-216-295-11 SHORT
1-216-295-11 SHORT
0
0
0
< IC >
IC1
IC5
IC7
IC501
8-752-095-36
8-752-914-87
8-759-832-99
8-752-392-04
IC
IC
IC
IC
CXA2596M-T6
CXP84640-072Q
LA6576L-TE-L
CXD2598Q
< JUMPER RESISTOR >
JR501
JR505
1-216-295-11 SHORT
1-216-864-11 SHORT
0
0
59
CDX-CA850/CA850X/CA860X
SERVO
Ref. No.
JR506
SUB
Part No.
SUB (CD)
Description
1-216-864-11 SHORT
Remark
Ref. No.
0
< TRANSISTOR >
Q101
8-729-904-87 TRANSISTOR 2SB1197K-T-146-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-847-11
1-216-847-11
1-216-801-11
1-216-857-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150K
150K
22
1M
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R106
R107
R108
R109
R110
1-216-857-11
1-216-835-11
1-216-838-11
1-216-801-11
1-216-843-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
15K
27K
22
68K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R111
R113
R122
R123
R127
1-216-842-11
1-216-839-11
1-216-845-11
1-216-839-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56K
33K
100K
33K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R213
R301
R302
R303
R304
1-216-821-11
1-216-843-11
1-216-839-11
1-216-821-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
68K
33K
1K
33K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R306
R307
R308
R309
R310
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R311
R312
R313
R314
R315
1-216-833-11
1-216-845-11
1-216-842-11
1-216-842-11
1-216-842-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
56K
56K
56K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R316
R317
R318
R319
R320
1-216-842-11
1-216-838-11
1-216-842-11
1-216-842-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56K
27K
56K
56K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R321
R322
R501
R503
R504
1-216-846-11
1-216-835-11
1-216-833-11
1-216-845-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
120K
15K
10K
100K
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R505
R506
R507
R511
R513
1-216-839-11
1-216-845-11
1-216-827-11
1-216-845-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
100K
3.3K
100K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R516
1-216-845-11 METAL CHIP
100K
5%
1/16W
60
Part No.
Description
R517
R518
R519
R520
R521
1-216-837-11
1-216-834-11
1-216-834-11
1-216-834-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
12K
12K
12K
12K
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R522
R523
R524
R526
R527
1-216-834-11
1-216-834-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
12K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R531
R532
R533
R535
R551
1-216-809-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
100K
100K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R552
R553
R554
R555
R558
1-216-841-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
47K
100K
100K
100K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R560
R563
R564
R568
R569
1-216-809-11
1-216-809-11
1-216-845-11
1-216-837-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
22K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R570
R572
R590
R594
R595
1-216-821-11
1-216-809-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R599
1-216-821-11 METAL CHIP
1K
5%
1/16W
< VIBRATOR >
X1
1-781-758-21 VIBRATOR, CERAMIC (CHIP TYPE) (10MHz)
X2
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16MHz)
*************************************************************
1-659-834-11 SUB BOARD
**********
*
< CONNECTOR >
CN1
1-770-347-21 CONNECTOR, FPC 6P
*************************************************************
1-680-868-11 SUB (CD) BOARD
**************
*
1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)
3-039-443-11 SHEET (CONNECTOR)
*
< CAPACITOR >
C852
C853
1-162-960-11 CERAMIC CHIP
1-162-960-11 CERAMIC CHIP
220PF
220PF
10%
10%
50V
50V
CDX-CA850/CA850X/CA860X
SUB (CD)
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
< CONNECTOR >
CN852
D851
8-719-078-81 DIODE DF5A6.8FU(TE85R)
D852
8-719-078-81 DIODE DF5A6.8FU(TE85R)
LED851 8-719-082-38 LED CL-270SR-C-TS (INSERT MARK)
< SWITCH >
LSW851 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z)
< RESISTOR >
R855
1-219-286-11 METAL CHIP
680
2%
1/16W
R856
1-219-286-11 METAL CHIP
680
2%
1/16W
*************************************************************
#1
#2
#3
#4
#5
7-685-790-01
7-685-792-09
7-621-772-20
7-685-646-79
7-685-794-09
SCREW +PTT 2.6X4 (S)
SCREW +PTT 2.6X6 (S)
SCREW +B 2X5
SCREW +BVTP 3X8 TYPE2 N-S
SCREW +PTT 2.6X10 (S)
#6
#7
#8
#9
#10
7-685-793-09
7-685-797-09
7-685-105-19
7-627-553-37
7-627-553-17
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X16 (S)
SCREW +P 2X8 TYPE2 NON-SLIT
SCREW, PRECISION +P 2X3 TYPE3
SCREW, PRECISION +P 2X2 TYPE3
#11
7-628-253-00 SCREW +PS 2X4
#12
7-627-850-28 SCREW, PRECISION +P 1.4X3
#13
7-628-253-15 SCREW +PS 2X5
*************************************************************
MISCELLANEOUS
***************
9
9
24
201
207
1-776-207-72 CORD (WITH CONNECTOR) (POWER)
(CA850X/CA860X)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(CA850)
1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)
X-3378-598-1 CHASSIS (OP) ASSY (including M901)
1-659-880-11 MOTOR FLEXIBLE BOARD
0 210
8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP
212
1-676-707-21 PICK-UP FLEXIBLE BOARD
F901
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3291-674-A MOTOR ASSY, SLED (SLED)
M903
A-3315-039-A MOTOR SUB ASSY, LD (LOADING)
*************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
1-476-546-31 REMOTE COMMANDER (RM-X113) (CA850)
1-476-546-41 REMOTE COMMANDER (RM-X112)
(CA850X/CA860X)
1-476-589-11 REMOTE COMMANDER (RM-X5S)
3-020-953-01 LABEL (MODE) (for RM-X5S)
3-229-196-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,
DUTCH,ITALIAN,GERMAN) (CA850)
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
251
252
253
254
255
X-3373-602-1
3-386-828-01
3-349-410-01
X-3366-405-1
3-924-961-01
FRAME ASSY
SCREW, FITTING (CA850)
BUSHING (CA850)
SCREW ASSY (EXP), FITTING (CA850)
SUPPORT (ND), FITTING (CA850X/CA860X)
256
257
258
259
260
7-682-160-01
X-3368-725-1
3-040-979-01
3-934-325-01
1-465-459-21
SCREW +P 4X6 (CA850X/CA860X)
SCREW ASSY, FITTING (CA850X/CA860X)
COLLAR
SCREW, +K (5X8) TAPPING
ADAPTOR, ANTENNA (CA850)
261
262
3-041-000-01 SPRING, FITTING
1-776-207-72 CORD (WITH CONNECTOR) (POWER)
(CA850X/CA860X)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(CA850)
7-685-248-14 SCREW +KTP 3X12 TYPE4 (for RM-X5S)
3-231-381-01 STRAP (ROTARY COMMANDER) (for RM-X5S)
263
264
265
* 266
267
3-671-893-00 CLAMP (LOW TYPE) (for RM-X5S)
X-3373-432-1 BRACKET ASSY (for RM-X5S)
251
254
255
252
3-229-196-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
SWEDISH,PORTUGUESE,GREEK,RUSSIAN)
3-229-198-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,
SPANISH) (CA850X/CA860X)
3-229-199-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH,SPANISH) (CA850X/CA860X)
3-229-200-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH,DUTCH,ITALIAN,GERMAN)
(CA850)
3-229-200-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,SWEDISH,PORTUGUESE,
GREEK,RUSSIAN)
3-230-549-01 LID, BATTERY CASE (for RM-X112/X113)
X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL)
*************************************************************
Remark
**************
HARDWARE LIST
**************
1-794-064-12 SOCKET, CONNECTOR 14P
< DIODE >
Description
257
253
258
259
256
260
267
264
261
262
265
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
263
266
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
61
CDX-CA850/CA850X/CA860X
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.1
1.0
62
Date
2001. 04
2001. 02
Description of Revision
Change the page of exploded views.
New