1
Download Lochinvar A05H00172528 User's Manual
Transcript
PB-PF-RP-05 Replacement Parts List PARTS & SERVICE DEPARTMENT Nashville, Tennessee 615-889-8900 • Fax: 615-547-1000 www.Lochinvar.com Power-Fin® Heating Boilers & Hot Water Supply Boilers PB/PF 501 thru 1300 Starting Serial #A05H00172528 29 33 15 3 16 17 32 11 CONTROL PANEL ASSEMBLY 8 6 6 8 14 31 9 1 7 F-9 31 12 13 1 7 M-9 GAS TRAIN ASSEMBLY 2 HEAT EXCHANGER ASSEMBLY ITEM NO. 1 1 1 1 1 2 2 3 4 4 5 6 7 7 7 8 9 PART NO. 11 11 12 13 14 15 15 15 16 17 17 17 17 17 17 17 17 TST2314 RLY3109 RLY3110 RLY3111 TST5314 TST2032 WRE2145 GTP2900 HLC2510 HLC2702 PLT3400 RLY2402 PAN3445 PAN3444 PAN3442 TRF2005 RLY2052 RLY2107 RLY2108 RLY2724 RLY2110 RLY2111 RLY2706 RLV2001 RLV2003 RLV2007 WTR2040 PRS2431 PRS2432 PRS2433 PRS2434 PRS2435 PRS2436 PRS2437 PRS30000 18 18 18 18 19 19 19 19 20 20 21 21 21 21 22 22 23 23 23 23 23 23 23 23 BNR3713 BNR3714 BNR3715 BNR3716 VAL2714 VAL2715 VAL2716 VAL2717 VAL2018 VAL2019 VAL2718 VAL2519 VAL2719 VAL2520 GAC2029 GAC2030 ORF2762 ORF2763 ORF2764 ORF2765 ORF2766 ORF2767 ORF2768 ORF2769 MODEL NUMBER DESCRIPTION CONTROLS & GAUGES THERMOSTAT, CONTROLLER CONTROL BOARD, WITH I/O RESET CONTROL BOARD CONTROL BOARD THERMOSTAT, CONTROLLER THERMOSTAT SENSOR THERMOSTAT SENSOR GAUGE, TEMP AND PRESSURE THERMOSTAT, HI LIMIT 200 DEGREE THERMOSTAT, HI LIMIT W/ MANUAL RESET IGNITOR, HOT SURFACE MODULE, IGNITION CONTROL PANEL CONTROL PANEL CONTROL PANEL TRANSFORMER (75VA) PUMP RELAY POWER BOARD DISPLAY BOARD DISPLAY BOARD 4 POLE RELAY 4 POLE RELAY BASE PUMP RELAY RELIEF VALVE, PRESSURE ONLY RELIEF VALVE, PRESSURE ONLY RELIEF VALVE, TEMPERATURE & PRESSURE FLOW SWITCH SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR SWITCH, LOW AIR GAS TRAIN ASSEMBLIES BURNER BURNER BURNER BURNER VALVE, GAS VALVE, GAS VALVE, GAS VALVE, GAS VALVE, GAS 1" VALVE, GAS 1-1/4" VALVE, MAIN GAS 1" VALVE, MAIN GAS 1" VALVE, MAIN GAS 1-1/4" VALVE, MAIN GAS 1-1/4" GAS COCK GAS COCK ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER ORIFICE, BURNER 3 PB - F9 PB - M9 PF - M9 PB - M9 PF F9 M9 PB PF ALL ALL ALL PB - M9 PB - F9 PF ALL F9 F9 F9 M9 M9 M9 M9 PB 501-1001 PB 1300 PF ALL 501 - LP - F9 501- NAT - F9 751 - LP - F9 751 - NAT - F9 1001 - LP - F9 1001 - NAT - F9 ALL 1300 - F9 PB501-1300 M9 NAT & LP 501 751 1001 1300 501 - M9 751 - M9 1001 - M9 1300 - M9 501 - F9 751-1001-1300 - F9 501 - NAT - F9 501 - LP - F9 751-1001-1300- NAT - F9 751-1001-1300 - LP - F9 501 751-1001-1300 501 - NAT - F9 751 - NAT - F9 1001 - NAT - F9 1300 - NAT - F9 501 - LP - F9 751 - LP - F9 1001 - LP - F9 1300 - LP - F9 ITEM NO. PART NO. 24 24 24 24 24 24 24 24 25 25 25 25 26 27 27 HEX3228 HEX3236 HEX3229 HEX3237 HEX3230 HEX3238 HEX3231 HEX3239 JKH2016 JKH2017 JKH2018 JKH2019 JKP6569 TST2300 TST2306 28 29 30 31 32 33 34 35 36 37 38 39 ARM3022PAB ARM3025PAB PUM3006 FAN3727 FAN2027 MSC2731 SWT2004 SWT2006 FIL2001 GKT2012 GKT2053 GKT2033 GKT2034 GKT2035 GKT2036 GKT2705 MSC2975 KIT3064 KIT3065 KIT3066 KIT3067 KIT3068 KIT3070 - MODEL NUMBER DESCRIPTION HEAT EXCHANGER ASSEMBLIES HEAT EXCHANGER(HLW) HEAT EXCHANGER (H) HEAT EXCHANGER(HLW) HEAT EXCHANGER (H) HEAT EXCHANGER(HLW) HEAT EXCHANGER (H) HEAT EXCHANGER(HLW) HEAT EXCHANGER (H) V BAFFLE (20 REQ.) V BAFFLE (20 REQ.) V BAFFLE (20 REQ.) V BAFFLE (20 REQ.) V BAFFLE STRAP (500 - 2 REQ.) (750-1300 - 3 REQ.) HIGH LIMIT BULBWELL OPERATOR BULBWELL MISCELLANEOUS PUMP PUMP STARTING SERIAL#F05H00177438 PUMP STARTING SERIAL#B0600183977 FAN, COMBUSTION AIR FAN, VENTILATION BURNER SIGHT GLASS RESET BUTTON ON/OFF SWITCH AIR FILTER IGNITOR GASKET JACKET GASKET FLANGE GASKET BURNER/BLOWER GASKET BURNER/ HEX GASKET HEX/INNER TOP GASKET HEX/DIVIDER PANEL GASKET CONDENSATE TRAP KIT, OUTDOOR AIR RESET KIT, OUTDOOR AIR RESET KIT, ALARM ON ANY FAILURE WITH BELL KIT, ALARM ON ANY FAILURE WITH BELL KIT, MANUAL RESET LOW WATER CUTOFF KIT, LOUVER CONTACTS 501 501 751 751 1001 1001 1300 1300 501 751 1001 1300 ALL ALL ALL ALL PF PF751-1300 PF501 ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL PB-F9 PB-M9 ALL F9 ALL M9 ALL ALL PLEASE HAVE MODEL NUMBER AND SERIAL NUMBER WHEN ORDERING PARTS. ©-6/08-Printed in U.S.A. 4
