1
Download Lochinvar Intelli-Fin IB 1500 User's Manual
Transcript
IFR-06 Replacement Parts List PARTS AND SERVICE DEPARTMENT Nashville, Tennessee 615-889-8900 • Fax: 615-547-1000 www.Lochinvar.com Intelli-Fin® Boilers/Water Heaters IB/IW 1500, 1700, 2000 42 41 47 40 48 46 45 46 44 45 1 HEAT EXCHANGER ASSEMBLY 27 23 28 29 24 30 39 39 31 32 34 35 33 48 26 36 37 38 IFR-06 2 of 4 GAS TRAIN ASSEMBLY CONTROL PANEL 21 11 17 25 22 16 18 20 15 13 131214 12 12 12 1 1 19 3 2 9 8 3 7 4 ITEM NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 15 15 15 16 17 - HLC2702 LHT2001 SWT2001 SWT2002 SWT2003 SWT2000 RLY3717 RLY2402 SWT2004 RLY3020 RLY2718 RLY2902 RLY2708 RLY2706 WTR2530 WTR30000 WTR2528 WTR30001 WTR2532 WTR2222 WTR2533 WTR20000 TRF2010 RLY3027 WRE3702 MSC2549 18 19 19 20 21 21 21 22 23 23 23 VAL2044 VAL2710 VAL2711 VAL3004 FAN3006 FAN3007 FAN3008 GKT2000 BNR3419 BNR3420 BNR3421 IFR-06 5 6 DESCRIPTION CONTROLS HIGH LIMIT, MANUAL RESET LIGHT, 24 VAC INDICATOR SWITCH, ON/OFF SWITCH, MOMENTARY OFF (RED) SWITCH, MOMENTARY OFF (BLACK) SWITCH, ON/OFF POWER COMMAND DISPLAY MODULE, IGNITION SWITCH, ROUND PUSHBUTTON VARIABLE FREQUENCY DRIVE MODULE, PULSE TO ANALOG RELAY, 24 VOLT CONTROL RELAY, IGNITION ENABLE RELAY, PUMP LOW WATER CUT-OFF, MANUAL RESET (OPTIONAL) PRIOR TO H08H00211245 LOW WATER CUT-OFF, MANUAL RESET (OPTIONAL) BEGINNING H08H00211245 LOW WATER CUT-OFF, AUTO RESET (OPTIONAL) PRIOR TO H08H00211245 LOW WATER CUT-OFF, AUTO RESET (OPTIONAL) BEGINNING H08H00211245 LOW WATER CUT-OFF PROBE (OPTIONAL) PRIOR TO H08H00211245 LOW WATER CUT-OFF PROBE (OPTIONAL) BEGINNING H08H00211245 LOW WATER CUT-OFF BOOT (OPTIONAL) PRIOR TO H08H00211245 LOW WATER CUT-OFF BOOT (OPTIONAL) BEGINNING H08H00211245 TRANSFORMER 120 VOLT INTERFACE BOARD/XL-10 PROGRAMMED VFD RESET (ONLY USED WITH SP200) TERMINATOR MODULE GAS TRAIN ASSEMBLIES VALVE, MAIN GAS VALVE, 1-1/2" BODY AUTO PROPORTIONING VALVE, 2" BODY AUTO PROPORTIONING ACTUATOR KIT FAN KIT FAN KIT FAN KIT GASKET, ORIFICE HOLDER BURNER ASSEMBLY BURNER ASSEMBLY BURNER ASSEMBLY 3 of 4 MODEL NO. ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL 1500 1700-2000 ALL 1500 1700 2000 ALL 1500 1700 2000 ITEM NO. PART NO. 24 25 27 28 29 30 - GKT2102 RLY2043 PLT3400 GKT2012 GKT2103 MSC2731 TST2409 WRE2143 WRE2135 36 36 36 36 36 36 48 31 32 33 26 34 35 37 38 39 48 48 48 HEX3060 HEX3061 HEX3062 HEX3068 HEX3069 HEX3070 HEX3067 TST2300 GKT2006 JKH6431 JKH6828 GKT2006 WTR4708 GKT2006 DRV3800 TST2306 JKH2012 JKH2013 JKH2014 40 40 41 41 42 42 42 44 45 46 47 - VAL2058 VAL2158 GTP2900 GTP3000 RLV2016 RLV2003 RLV2001 JKH6863 JKH6818 GKT2434 ARM3072PBF KIT3002 PRS2007 JKH6865 MSC2465 LHT2000 SWT2005 FIB2104 FIB2105 FIB2106 FIB2107 FIB2108 FIB2109 FIB2110 FIB2111 FIB2112 FIB2113 FIB2114 GKT2053 KIT3000 KIT3046 MSC2976 MSC2737 WRE2106 WTR2140 IFR-06 DESCRIPTION GAS TRAIN ASSEMBLIES (Continued) BURNER GASKET WING BOARDS IGNITOR, HOT SURFACE GASKET, IGNITOR GASKET, BLOWER SIGHT GLASS INLET/OUTLET BYPASS SENSOR INLET SENSOR HARNESS W/ PLUG BYPASS/OUTLET ASSEMBLY HEAT EXCHANGERS HEAT EXCHANGER (HLW) HEAT EXCHANGER (HLW) HEAT EXCHANGER (HLW) HEAT EXCHANGER (H) HEAT EXCHANGER (H) HEAT EXCHANGER (H) HEAT EXCHANGER, SECONDARY BULBWELL THERMOSTAT, 3/8" (HIGH LIMIT) GASKET, FLANGE RETAINER UPPER V-BAFFLE RETAINER LOWER V-BAFFLE GASKET, TOP HEADER FLANGE FLANGE, CAST GASKET, FLANGE FOR DRAIN VALVE DRAIN PIPE ASSEMBLY BULBWELL THERMOSTAT, 3/8" V-BAFFLE V-BAFFLE V-BAFFLE MISCELLANEOUS VALVE, ACTUATOR BEFORE SERIAL J04 VALVE, ACTUATOR BEGINNING SERIAL J04 GAUGE, PRESSURE & TEMPERATURE GAUGE, TEMPERATURE VALVE, TEMPERATURE & PRESSURE VALVE, PRESSURE 1" VALVE, PRESSURE 3/4" (2 REQ'D.) JACKET, BACK SECONDARY HEX ACCESS FLANGE, PIPE GROMMET, PIPE PUMP PRESSURE SWITCH PRESSURE SWITCH (AFTER F05) DOOR, FRONT UPPER OUTER CIRCUIT BREAKER LIGHT, 24 VAC INDICATOR SWITCH, LEVER HANDLE INSULATION TOP INSULATION BACK INSULATION FRONT DOOR INSULATION FRONT DOOR INSULATION FRONT DOOR INSULATION FRONT INSULATION FRONT INSULATION FRONT INSULATION SIDE INSULATION SIDE INSULATION SIDE GASKET, JACKET NEUTRALIZING KIT BEFORE K05 NEUTRALIZING KIT AFTER K05 CONDENSATE TRAP AFTER K05 BLOCKED DRAIN COMMUNICATION WIRE (PURCHASE BY THE FOOT) FLOW SWITCH PLEASE PROVIDE MODEL & SERIAL NUMBER WHEN ORDERING PARTS. 4 of 4 MODEL NO. ALL ALL ALL ALL ALL ALL ALL ALL ALL IW1500 IW1700 IW2000 IB1500 IB1700 IB2000 ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL 1500 1700 2000 ALL ALL IB IW IW IB1500 & 1700 IB2000 ALL ALL ALL IF ALL ALL ALL ALL ALL ALL ALL ALL 1500 1700 2000 1500 1700 2000 1500 1700 2000 ALL ALL ALL ALL ALL ALL ALL 10/08-Printed in U.S.A.
