Download Sampo SME-32DL5 32" TV
Transcript
MMM-0023 VER1.0 34“ MULTIMEDIA MONITOR SERVICE MANUAL MODEL:SME-32DL5(P) VER1.0 CONTENTS 1. IMPORTANT SAFETY PRECAUTIONS......... 1-1 2. BLOCK DIAGRAM........................................... 2-1 3. FACTORY & ELECTRONIC ADJUSTMENT... 3-1 4. TROUBLE SHOOTING GUIDES.............….... 4-1 5. SPECIFICATION......................................…... 5-1 6. EXPLODED VIEW.....................................…. 6-1 7. P.C. BOARD TOP VIEW ............................... 7-1 8. SCHEMATIC DIAGRAM ................................ 8-1 9. ELECTRONIC PARTS LIST .......................... 9-1 If having any changes, do not do advanced advice. 10.DEFECT BAR CODE LIST….………………10-1 11.PACKING OF THE SET……………………..11-1 If having any changes, do not do advanced advice. SAFETY PRECAUTIONS VER 1.0 SHOCK HAZARD THAT MUST ELIMINATED BEFORE RETURNING INSTRUMENT TO THE CUSTOMER. 1. Before returning an instrument to the customer, always make a safety check of the entire instrument, including, but not limited to, the following items. a. Be sure that no built-in protective devices are defective and/or have been defeated during servicing. (1) Protective shields are provided on this chassis to protect both the technician and the customer. Correctly replace all missing protective shields, including any removed for servicing convenience. (2) When reinstalling the chassis and/or other assembly in the cabinet, be sure to put back in place all protective devices, including, but not limited to, nonmetallic control knobs, insulating fishpapers, adjustment and compartment covers/shields, and isolation resistor/capacitor networks. Do not operate this instrument or permit it to be operated without all protective devices correctly installed and functioning. AC Leakage Test LEAKAGE CURRENT TESTER DEVICE UNDER TEST BE THE (READING SHOULD NOR BE ABOVE 3.5mA) + TEST ALL EXPOSED METAL SURFACES 3. WIRE CORD ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED) EARTH GROUND 2. Read and comply with all caution and safety-related notes on or inside the Monitor cabinet, on the Projection Monitor chassis, or on the picture tube. b. Be sure that there are no cabinet openings through which an adult or child might be able to insert their fingers and contact a hazardous voltage, Such opening include, but are not limited to, (1) spacing between the picture tube and the cabinet mask, (2) excessively wide cabinet ventilation slots, and (3) an improperly fitted and/or incorrectly secured cabinet back cover. 3. Design Alteration Warning— — Do not alter or add to the mechanical or electrical design of this unit. Design alterations and additions, including, but not limited to, circuit modifications and the addition of the items such as auxiliary audio and/or video output connections might alter the safety characteristics of this Projection Monitor and create a hazard to the user. Any design alterations or additions will void the manufacturer’s warranty and will make you, the service, responsible for personal injury or property damage resulting therefrom. c. Leakage Current Hot Check — With the instrument completely reassembled, plug the AC line cord directly into a 120V AC outlet. (Do not use an isolation transformer during this test.) Use a leakage current tester or a metering system that complies with American National Standards Institutes (ANSI) C101.1 Leakage Current for Appliances and Underwriters Laboratories (UL) 478. With the instrument AC switch first in the ON position and then in the OFF position, measure from a known earth ground (metal waterpipe, conduit, etc.) to all exposed metal parts of the instrument (antennas, handle bracket, metal cabinet, screwheads, metallic overlays, control shafts, etc.), especially any exposed metal parts that offer an electrical return path to the chassis. Any current measured must not exceed 3.5 milliamp. Reverse the instrument power cord plug in the outlet and repeat test. ANY MEASUREMENTS NOT WITHIN THE LIMITS SPECIFIED HEREIN INDICATE A POTENTIAL 4. Hot Chassis Warning — a. Some Monitor chassis are electrically connected directly to one conductor of the AC power cord and may be safely serviced without an isolation transformer only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC power source. To confirm that the AC power plug is inserted correctly, with an AC voltmeter measure between the chassis and a known earth ground. If a voltage reading in excess of 1.0V is obtained, remove and reinsert the AC power plug in opposite polarity and again measure the voltage potential between the chassis and a 1-1 SAFETY PRECAUTIONS VER 1.0 known earth ground. b. Some Monitor chassis normally have 85V AC (RMS.), between chassis and earth ground regardless of the AC plug polarity. These chassis can be safely serviced only with an isolation transformer inserted in the power line between the receiver and the AC power source, for both personnel and test equipment protection. c. Some Projection Monitor chassis have a secondary ground systems in addition to the main chassis ground. This secondary ground system is not isolated from the AC power line. The two ground system are electrically separated by insulating material that must not be defeated or altered. 5. Observe original lead dress. Take extra care to assure correct lead dress in the following areas: a. near sharp edges, b. near thermally hot parts—be sure that leads and components do not touch thermally hot parts, c. the AC supply, d. high voltage, e. antenna wiring. Always inspect in all areas for pinched, out-of-place, or frayed wiring. Do not change spacing between components, and between components and the printed-circuit board. Check AC power cord for damage. 6. Components, parts, and/or wiring that appear to have overheated or are otherwise damaged should be replaced with components, parts, or wireing that meet original specifications. Additionally, determine the cause of overheating and/or damage and, if necessary, take corrective action to remove any potential safety hazard. 7. PRODUCT SAFETY NOTICE— — Many Monitor electrical and mechanical parts have special safety-related characteristics some of which are often not evident from visual inspection, nor can the protection they give necessarily be obtained by replacing them with components rated for higher voltage, wattage, etc. Parts that have special safety characteristics are identified in this service data by shading with a mark on schematics and by shading or a mark in the parts list. Use of a substitute replacement part that does not have the same safety characteristics as the recommended replacement part in this service data parts list might create shock, fire, and/or other hazards. 1-2 VER1.0 BLOCK DIAGRAM Total block diagram YCBCR AV1 L◎ R◎ V◎ AV2 L◎ R◎ V◎ AV3 AV OUT L◎ R◎ L◎ R◎ V◎ S I/P RGB I/P TA8184 SOUND CONTROL L PHONE R L R V R G B CRT AMP H V DEF. BLOCK AV BLOCK AUX POWER AC LINE TDA2616 SOUND AMP ○ ○ ○ POWER 2-1 CRT VER1.0 BLOCK DIAGRAM Monitor DEF. & CRT AMP block diagram Main Board signals output R CRT BOARD CRT G TDA4885: IC901 AMP:Q903,905,907 B H.V. Feedback IIC BUS H PC87C380 H IC001 V V C O N T R O L B U S Dynamic Focus:IC6C1 TDA4854 (DEF.IC) IC691 V2 3843 IC661 DC converter IRF740:T604 H.V. 74HC221:IC631 MAIN BOARD H-DEF Feedback R674,675,676 AMP/DAMP:Q601,T601 H V H.V. Cs linear C608,609,L601,602 Sidepin:Q6I1,6I2,L6I1 FOCUS H.V. 31KV DC-converter:T604,Q6D4 FBT T6C2 AMP/DAMP:Q6C9,C6D2 H-YOKE V-AMP TDA8351:IC501 V-YOKE SB 210V SB1 H-size H V RGB/TV V0 V1 LM358 IC632 POWER CIRCUIT 190V 28V 13V AC IN 19V 6.3V Sub power and Sound board 2-2 R L VER1.0 BLOCK DIAGRAM Main power supply & Aux. power & sound AMP block diagram SB1 CPU pin20 DEGA IC713 AC Input EMI Filter T702,T703 Protect Bridge & Rectifier BR701 X‘ FMR T701 Low Voltage Protection Q711,Q712,Q713 PWM IC IC711 Feedback Network IC712 DC Rectifier & Filter:D757 6.3V (0.63A) Rectifier & Filter:D755 19V (0.4A) Rectifier & Filter:D756 13V (0.4A) Rectifier & Filter:D759 28V (0.2A) Rectifier & Filter:D753 210V (0.6A) Rectifier & Filter:L751 190V (0.11A) Sevices Regulator SB CPU pin28 Rectifier & Filter:IC781 Stand by +5V Rectifier & Filter:D790 Stand by +12V Rectifier & Filter:D789 30V TO CPU Switch IC716~D788 T781 Sound control Sound L R TA8184 IC301 Pre-AMP IC302~309 AMP TDA2616 IC311 2-3 SPEAKERS VER1.0 BLOCK DIAGRAM AV. Board YCBCR AV1 AV2 VIDEO SWITCH IC803 YUV R L V R L Y AV SWITCH IC806 V IC807 TC9090AN R G B C to Main board IC801 TB1276AN V AV OUT V R L Sound (R) Sound (L) H See Page5 SOUND BLOCK S I/P RGB I/P R/G/B/H/V (VGA) 5V 9V 2-4 to CPU FACTORY & ELECTRONIC ADJUSTMENT VER 1.0 WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAUTION” AND “PRODUCT SAFETY NOTICE” ON PAGE 1 AND 2 OF THIS MANUAL. SET-UP ADJUSTMENT zThe following adjustments should be made when a complete realignment is required or a new picture tube is installed. Perform the adjustments in order as follows : 1. Purity 2. Distortion (Vertical) balance 3. Convergence 4. Focus Note: The PURITY/CONVERGENCE MAGNET assembly and rubber wedges need mechanical positioning. PART DESCRIPTION PART NO. CPT Picture tube, M81AHM50X01 VBM81AHM50X01 DY Deflection yoke, YS-70840 RDY-N1004-1---3 DEFLECTION YOKE (DY) 2 2 RUBBER WEDGE 40MAX (Tape) ADHESIVE (Silicon) 90MAX PURITY/ CONVERGENCE MAGNET ASS‘Y (CPM) DEFLECTIO N YOKE (DY) 1 3-1 FACTORY & ELECTRONIC ADJUSTMENT VER 1.0 PURITY ADJUSTMENT NOTE: 1. 2. Before attempting any PURITY ADJUSTMENTS, the receiver should be operated for at least 30 minutes at White Rasher. Demagnetize the picture tube and cabinet using a degaussing coil. (East direction) Slowly move the DY forward or backward with moving 2 pole magnet of CPM until Green beam registration rank “a” is become Tighten the clamp screw of the DY with correct rasher-rotation. Registration Rank Rasher-rotation Face to south a a +0.74 1 dot -0.74 1 dot 60mm ■ DISTORTION (VERTICAL) BALANCE ADJUSTMENT Tilt front of DY up or down to obtain best balance of Top and Bottom distortion. ■ CONVERGENCE ADJUSTMENT NOTE: Before attempting any convergence adjustment the receiver should be operated for at least 15 minutes. 1.Pan front of DY right or left to obtain better convergence of Yv (R or B wide pattern), and put d WEDGE into right and left space with temporary Mounting WEDGE. R B B R 3-2 FACTORY & ELECTRONIC ADJUSTMENT VER 1.0 2. Xv misconvergence adjustment: Adjust the Xv coil (on the deflection yoke) to correct misconvergence at both sides on screen. (See the figure below.) Use a hexagonal tip stick (plastic) to adjust the core of coil. Clockwise Counterclockwise R B B R B R R B Xv Cross Pattern View 3. Center convergence adjustment 1) Receive crosshatch pattern from a color bar/pattern generator. 2) Adjust the BRIGHTNESS and CONTRAST Controls for well defined pattern. 3) Adjust two tabs of the 4-Pole Magnets to change the angle between them (See figure 3.) and superimpose red and blue vertical lines in the center area of the picture screen.(See figure 4.) 4) Turn the both tabs at the same time keeping the constant angle to superimpose red and blue horizontal lines at the center of the screen. (See figure 4) ADJUST THE ANGLE (VERTICAL LINES) 5) Adjust tow tabs of 6-Pole Magnets to superimpose red/blue line with green one. Adjusting the angle affects the vertical lines and rotating both magnets affects the horizontal lines. 6) Repeat adjustments 3, 4, 5 keeping in mind red, green and blue movement, because 4-Pole Magnets and 6-Pole magnets interact and make dot movement complex. FIXED ROTATE TWO TABS AT THE SAME TIME (HORIZONTAL LINES) ADJUSTMENT OF MAGNETS Figure 3. BLUE RED RED/BLUE GRN RED/BLUE BLUE RED GRN 4-POLE MAGNETS MOVEMENT 6-POLE MAGNETS MOVEMENT Center Convergence by Convergence Magnets Figure 4. 3-3 FACTORY & ELECTRONIC ADJUSTMENT 4. Corner convergence adjustment: When the misconvergence is still evident on corners even though the above adjustment is done, use the ferrite sheet to correct misconvergence. Put ferrite sheets into the space under the yoke. Decide such position that misconvergence becomes minimum, watching picture screen. (See figure below.) Remove cover paper of ferrite sheet to stick it in the place on the tube. Put adhesive tapes on ferrite sheets to fix. Ferrite Sheets ■ 1. 2. 3. 4. VER 1.0 FOCUS ADJUSTMENT Select the RGB mode. Receive the “H” character signal from VGA signal generator. Adjust the FOCUS control (FBT) and DYNAMIC FOCUS VR901 watching 4 corners for the best performance of a “H” character. Recheck overall convergence. Ferrite Sheet A For correcting misconvergence on the position A 3-4 FACTORY ADJUSTED METHOD AND ORDER 1.0 VER A. The entry method for factory setting item. 1. Push the factory setting button on the R/C to go to factory setting mode. 2. When the monitor set is in “on” condition, pull the AC cord away. Then push the POWER SW continuously and insert the AC cord again. Do not release the POWER SW until the screen appear raster. When the above steps completed, it is in factory setting mode. B. The selecting items of factory setting. 1. W-BALANCE ADJ. (white balance adjustment) 2. GEOMETRY ADJ. (geometry adjustment) 3. CHECK (factory check. It work for AV‘s function check) 4. AUTO RUN ( No use ) 5. MTS SET 6. MMM SET note: (1) Use the MENU +/- button to entry the desired selecting item. (2) Use the ADJ. +/- button to entry this selected item (3) Then use MENU +/- button again to select the adjusting items) note: Only the item 1 and 2 of the factory adjustment are used to adjust. The No. 3 item are used as the factory check. W-BALANCE ADJ. (white balance adjusting method) A. R.G.B.-BLACKLEVEL...................... black level adjusting of white balance B. R.G.B.-GAIN..................................... white level adjusting of white balance C. SUB-CONT-RGB D. SUB-CONT-AV E. SUB-TINT-AV F. SUB-COLOR-AV G. SUB-TINT YCBCR Step: 1. 2. 3. Set the BRIGHTNESS & CONTRAST at MAX. Adjust the R.G.B.-BLACKLEVEL to min. Do not adjust the background color. Then adjust the other two color to reach the standard color temperature (adjust the SCREEN VR at the same time) 4. Adjust R.B.-GAIN (G-GAIN fix at 150 to 180) to let the “x”, “y” value reach the standard color temperature. (forget the Y value preferential) 5. Adjust the SUB-CONT-RGB to let the “Y” value reach the standard value 6. Repeat item 1. to 3. to check the color temperature value of black level. The standard color temperature. Black level x: 270 y: 270 Y: 0.45FL White level x: 270 y: 270 Y: 85FL (100% Center block) 3-5 FACTORY ADJUSTED METHOD AND ORDER 1.0 VER GEOMETRY-ADJ. ITEM ADJ. H CORNER MENU+ MIN. MAX. H corner adjustment ( STD and CHG ) H-PIN-BALANCE H pincushion balance adjustment V-LINEARITY V linearity adjustment V-LIN-BALANCE V linearity balance adjustment PINCUSHION pincushion size adjustment ( STD and CHG ) TRAPEZOID trapezoid adjustment ( STD and CHG ) PARALLELOGRAM parallelogram adjustment ( STD and CHG ) V-SIZE V size adjustment V-CENTER V center adjustment H-WIDTH H width adjustment center point ( STD and CHG ) H-PHASE H phase adjustment Center point Rotation Rotation adjustment L BLK Left Half Blanking Adjustment ( this function no use ) R BLK Right Half Blanking Adjustment ( this function no use ) MENU - The standard size. H-Size: 620mm V-Size: 465mm 3-6 SERVICE MODE ADJUSTMENT (1) VER1.0 RGB MODE ITEM ADJUSTMENT PROCEDURE. 1. adjustment 1. Set to RGB mode. (VR731) 2. Receive all white pattern (H:31.47K V:60Hz 640X480 mode). 3. 4. Connect DC Volt-meter between cathode of D753 and ground. ± 0.5V output. Adjust VR731 for 210V± High voltage adjustment 1. Connect HV meter. (VR691) 2. Set to RGB mode. (H:31.47K V:60Hz 640X480 mode). 3. Receive CROSS HATCH pattern. 4. 5. Set contrast and bright to standard.(Recall value) Adjust VR691 to let the high voltage be 31± ± 0.5KV. 1. 2. Set to RGB mode. Receive CROSS HATCH pattern (H:43.27K V:85Hz 640X480 3. mode). Adjust VR601 to let the raster be located at center of CRT. 1. Set to RGB mode.(have nine mode) 2. 3. H-Center adjustment (VR601) 4. Trapezoid adjustment (under factory adjustment mode) 2. 3. 4. Receive CROSS HATCH pattern Entry the second item of factory adjustment. Find the trapezoid item and adjust the trapezoid to be best. 5. 6. 1. (under factory adjustment mode) 2. 3. Geometry adjustment V-Linear adjustment 1. (under factory adjustment mode) 2. 3. Set to RGB mode. .(have nine mode) Receive CROSS HATCH pattern Entry the item 2 of factory setting to select parallelogram item to adjust the parallelogram to be best. Set to RGB mode. Receive CROSS HATCH pattern (H:31.47K V:60Hz 640X480 mode). Entry item 2 and find V-Linearity adjustment of factory setting to adjust the V-linearity to be best. 7. 1. (under factory adjustment mode) 2. H-size adjustment (RGB mode) Set to RGB mode. Receive CROSS HATCH pattern (we have nine main modes, please see the specification of CHROMA-2135 generator pattern). 3. Entry the factory adjustment item 2 to choice the H-size adjustment. 4. Use the adjustment to let the H-size meet the specification ( 620mm for all main modes ) 3-7 SERVICE MODE ADJUSTMENT VER1.0 3-8 SERVICE MODE ADJUSTMENT VER1.0 ITEM ADJUSTMENT PROCEDURE. 8. V-size adjustment (RGB mode) 1. Set to RGB mode. 2. Receive CROSS HATCH pattern (we have nine main (under factory adjustment mode) modes, please see the specification of CHROMA-2135 generator pattern). 3. Entry the factory adjustment item 2 to choice the V-size adjustment. 4. Use the adjustment to let the V-size meet the specification ( 465mm for all main modes ) 9. Focus adjustment 1. Set to RGB mode. (VR901, FOCUS) 2. Receive H or @ pattern (H:37.8K V:72Hz 640X480 mode) or whole letter Picture. 3. Adjust VR901 on CRT PWB and FOCUS VR of FBT to let the picture clear both at center and corner. 10. White balance adjustment 1. (under factory adjustment mode) 2. 3. Set to RGB mode. (H:31.47K V:60Hz 640X480 mode). Receive back ground pattern (no Video Signal). Press MENU key to select bright function and set bright function to max. by pressing “+” key on remote control or volume “+” key front panel. Then press MENU key again to select contrast function. And set contrast function to max. by pressing “+” key on remote control or volume “+” key front panel. 4. Entry the item 1 of factory setting to adjust RGB-BLK LEVEL and let R.G.B.-BLK LEVEL are all minimum. 5. Adjust SCREEN VR to let the picture just bright. At this time the screen appears only one color of R or G or B. The BIAS of this color does not do any adjustment. 6. 7. Use CA-100 to measure the color temperature. Adjust the R.G.B. BLACK LEVEL of the other two color to let x=270, y=270. 8. Receive BLACK pattern. And adjust SCREEN VR to let Y=0.45± ± 0.2FL 9. Receive center white window single. 10. G-Gain fix in 150 to 180 and adjust R-Gain and B-Gain to ± 5 let x=270± ± 5, y=270± 11. Adjust contrast (Sub-CONT-RGB) to let Y=85FL± ± 2FL. 3-9 SERVICE MODE ADJUSTMENT VER1.0 (2) AV MODE ITEM 1 H-size adjustment (AV mode) (under factory adjustment mode) ADJUSTMENT PROCEDURE 1. 2. Set the AV mode (AV1). Receive Lion pattern. 54321 12345 H-steps (fig-1) V-steps digital test pattern→ →Lion pattern 3. The item 2 of factory setting is to adjust H-size. ± 0.5 . 4. Adjust H-Steps to be 5± 2 V-size adjustment (AV mode) (under factory adjustment mode) 3 Sub-Tint (Sub-Tint-AV) 1. 2. Press INPUT key to select AV1. Receive Lion pattern for AV1. (fig-1) 3. 4. Go to the item 2 of factory setting is to adjust V-Size. Adjust V-Steps to be 4± ± 0.5 . 1. Set the AV Mode(AV1) 2. 3. Receive Color Bar pattern with 8 steps. Connect the scope to Q813 Emitter. 4. Go to the factory setting. Select the Sub-Tint to adjust the Sub-Tint to be as follow. Sub-Tint 1 2 3 4 5. Let the below edge of step 2 and above edge of step 3 at the same level. 4 SUB Contrast ( Sub-CONT-AV) (Test point : B out ( Q813 “C” ) 1. 2. Set the AV Mode (AV1) Receive gray scale pattern with 8 steps. (no color) 3. 4. Connect the scope to Q813 Emitter. Go to the factory setting. Select the Sub-Contract (AV) to adjust the Sub-Contract (AV) to be as follow. 0.95Vp-p 3-10 SERVICE MODE ADJUSTMENT 5 SUB Color ( Sub-Color-AV) (Test point : B out ( Q813 “C” ) VER1.0 1. Set the AV Mode (AV1) 2. Receive Color Bar pattern . 3. Go to the factory setting. Select the Sub-Color-AV to adjust the Sub-Color to be as follow. 0.85Vp-p (3) YCBCR MODE ITEM Adjustment Procedure 1. Sub-Tint ( Sub-Tint YCBCR) 1. Set the YCBCR Mode 2. Receive Color Bar pattern with 8 steps. 3. Go to the factory setting. Select the Sub-Tint-YCBCR to adjust the Sub-Tint to be as follow. Sub-Tint 1 4. 2 3 4 Let the below edge of step 2 and above edge of step 3 at the same level. 3-11 TROUBLE SHOOTING FLOW CHART VER1.0 STAND-BY POWER Output voltage abnormal ± 4V Check Compare V C789=31V± output Voltage at C789 YES NO ±1V ﹖ Check C792=12V± YES Check Voltage at C709(+) NO Check output Replace stage abnormal parts Normal Check D789 Abnormal Check F701, IC716, ZD781, BR701 4-1 TROUBLE SHOOTING FLOW CHART VER1.0 MAIN POWER 1. NO MAIN POWER Is the main power in protection mode﹖ ﹖ YES NO Is the main power in over Is the main power in power load condition﹖ ﹖ saving mode﹖ ﹖ YES NO NO YES Check the Is the main Check the R.G.B. Is the Voltage of output stage power in under input cable and C757(210V) 210V Voltage signal source normal﹖ ﹖ condition﹖ ﹖ YES YES NO NO Is the voltage of Check IC711, Is there pulse Check IC713, IC713,IC712 and Q713,R723,R724, output from pin6 IC712, IC731 R725,D713 ﹖ of IC711﹖ and circuit IC001 pin20, ? pin25 4.5V? YES NO Check Q713, Check IC711 D713, ZD712 2. POOR LOAD REGULATION Check 208V VR731, C756 4-2 TROUBLE SHOOTING FLOW CHART 3. VER1.0 OVER VOLTAGE (1) 210V Is the Voltage C757(+) much higher than 210V YES NO Check Q731, IC712 Adjust VR731, Does the grounding path Voltage of C757(+) can adjust to 210V﹖ ﹖ YES (2) NO Adjust VR731 Check Voltage of C757(+) IC712, to 210V IC713 6.3V Is the Voltage of C765(+) much higher than 6.3V﹖ ﹖ YES NO Is the voltage of C757(+) much higher than 210V Check Voltage of C757(+) Adjust VR731 voltage of C757(+) to let 210V 4. THE VOLTAGE OF HEATER LOWER THAN 5.8V Is the voltage C757(+) much higher than 210V 5. THE PICTURE FROM R.G.B. OUTPUT IS NOT CLEAR ± 1KV of Check +190V and the high voltage 31KV± C753(+), C912, C909 4-3 TROUBLE SHOOTING FLOW CHART VER1.0 DEF. 1. NO RASTER(NO SOUND) Check +12V line on MAIN PWB Normal Too low or no voltage Check/replace Check/replace IC791, R791 IC711 Remains abnormal Check +13V output on MAIN POWER SUPPLY 2. NO RASTER(SOUND IS NORMAL) Da Da sound NO YES Check Q604, Q665, Heater element of CRT are lighting or no D603, D664, Q6C9, YES NO Check H.V. at anode of CRT Check heater connector on CRT BOARD Normal Abnormal Normal Check CRT socket Check D757, R748, Check 7V output on MAIN connections R758, C765, C756 POWER SUPPLY BOARD OK Normal Check CRT BOARD Check/replace assembly T701 4-4 Q6D4, L661 TROUBLE SHOOTING FLOW CHART 3. VER1.0 ONE HORIZONTAL LINE RASTER (NO VERTICAL SCAN) Check/replace IC501 Abnormal Normal Check +19V voltage Check VERT. YOKE connector Abnormal Check D759, Normal Check/replace IC691 C766,L757 4. ONE VERTICAL LINE RASTER (NO HORIZONTAL SCAN) Check/replace Q665, D664, Q604 Abnormal Normal Check IC661, IC631, IC632 Abnormal Check +12V voltage Check DY connector Normal Check/replace IC001 5. ABNORMAL CORNER FOCUS (ABNORMAL DYNAMIC FOCUS) Check/replace IC691, Q6C4, D6C1, D6C2 Check/replace T6C1 4-5 TROUBLE SHOOTING FLOW CHART 6. VER1.0 RASTER DISTORTION (SIDE PIN DISTORTION) Check/replace IC691 Check/replace Q6I1, Q6I2, Q6I3 Check/replace C6I1, R6I1, R6I2, L6I1 Check/replace D609, C623 7. OUT OF HORIZONTAL/VERTICAL SYNC. Check H & V sync singal input Good Failed Check IC001 Check the cable Good Failed Check/replace Replace IC001 IC691 4-6 TROUBLE SHOOTING FLOW CHART VER1.0 VIDEO 1. NO POWER Is the stand-by 5V normal﹖ ﹖ YES NO Normal power O/P of IC001 Check stand-by 5V pin20 or pin25? ? circuit YES NO Does RL701 act Check IC001 normally ﹖ NO YES Is the voltage of C709(+) Check R702, Q701, normal﹖ ﹖ D701, R701 YES NO Check Check IC711, Q713, R723, R724, R725, RL701, BR701 R713 and ZD712 2. NO OSD (On Screen Display) Is the OSD output signal of IC003 pin12,13,14,15 normal YES NO Check R906, R907, R908, R902, Check IC001,IC003 R903, R904 4-7 TROUBLE SHOOTING FLOW CHART 3. VER1.0 H-PHASE CAN NOT BE ADJUSTED. Is the voltage of IC001 pin7 H-PHASE normal﹖ ﹖ YES NO Does IC691 act Check IC001 normally? ? Check IC691 pin1 with or without the flyback pulse 4. OUT OF VERT SYNCHRONIZATION IN RGB MODE. Check D-SUB pin14 (V-SYNC IN) Is IC001 pin17 V-SYNC normal ? YES NO Check IC691 pin12, pin13 Check IC504 circuit triangle wave output Check IC501, R505,C503, R503, R504, C502, C501, R507, R501, R502 normal 4-8 TROUBLE SHOOTING FLOW CHART 5. NO ROTATION FUNCTION 6. VER1.0 H-SIZE CAN NOT BE ADJUSTED Is the rotation coil Check IC001 pin42 H-SIZE connector insert into RO control voltage Check Q691, Q692, Q693 Check IC631, IC632, IC661 control circuit H-SIZE adjustment control circuit 7. Check CPU and IC001 Check Q665, Q661, Q663, rotation circuit Q664, ZD661 NO VERTICAL SCAN Is D755(-) (19V) normal﹖ ﹖ YES NO Is IC691 pin12, pin13 V-RAMP O/P Check normal (normal triangle wave output? ?) D759 ,C766, L757, R505 YES NO Check Check IC691 IC501 pin7, pin9 Check VERT YOKE circuit 4-9 TROUBLE SHOOTING FLOW CHART 8. VER1.0 NO PICTURE Check the voltage of heater, B+190V, B+210V and C765(+) 6.3V. Are they normal﹖ ﹖ YES NO Check Q634, IC632, IC691 Check Q604, Q665 and and Q6C9 PWM circuit Check R6F9, X-RAY circuit 9. NO VIDEO IN AV INPUT MODE Check IC101,IC102 Check C861(+) AV 9V supply circuit Check IC801, IC802, IC816 and circuit Check IC806,IC807 and circuit 4-10 TROUBLE SHOOTING FLOW CHART VER1.0 AU D IO 1. NO AUDIO OUTPUT Is audio D789(-) B+30V normal﹖ ﹖ YES Check IC311 audio AMP circuit. NO Check F301 and audio 30V circuit Is IC301 pin2,19 sound input normal YES Check IC301 audio control circuit NO Check IC808,IC806 circuit volume tone, balance Check IC301,302,303 IC304,305,308 sound circuit and CPU control circuit 4-11 SPECIFICATION VER1.0 1. SCOPE These specifications describe all the characteristics of the 34 inch color monitor. 2. ELECTRICAL REQUIREMENTS 2.1. Cathode ray tube a. b. c. d. 2.2. Tube size Dot pitch Light transmission CRT TYPE NAME Power a. b. c. d. e. f. Input voltage Input current Inrush current Power consumption Line regulation Stand-by 2.3. Input signal 2.3.1 Video signal a. b. c. d. e. 2.3.2 Type Polarity Amplitude Input impedance Dot rate 100 ~ 240 Vac , 50 / 60 Hz 3 A at 110 Vac / 60 Hz 50 A 220 Watts 95 to 145 Vac / 60 Hz ~ 190 to 255 Vac / 50Hz less than 10 watts Analog Positive 0.714 VP-P 75 ohms 75M Hz (Max.) Horizontal sync a. b. c. d. 2.3.3 34 inch (4:3) H = 0.8 mm (center) 35.5% typical TOSHIBA Type Polarity Input impedance Frequency TTL Positive or Negative 1K ohms : 31KHz to 52KHz RGB AV,YCBCR : 15.734KHz (NTSC) / 60Hz : 15.625KHz (PAL) / 50Hz Vertical sync a. b. c. d. Type Polarity Input impedance Frequency TTL Positive or negative 1K ohm (Min.) 50 Hz to 120 Hz 2.3.4 Connector type 2.3.5 Pin assignments for D-SUB connector Pin 1 Pin 2 Pin 3 Pin 4 Pin 5 : : : : : RED GREEN BLUE GND GND 15 pin D-SUB and RCA JACK and S-terminal Pin 6 Pin 7 Pin 8 Pin 9 Pin 10 : : : : : RED GND GREEN GND BLUE GND NC GND 5-1 Pin 11 Pin 12 Pin 13 Pin 14 Pin 15 : : : : : GND SDA H-SYNC V-SYNC SCL SPECIFICATION 2.3.6 VER1.0 Preset timing chart A B C D F E (Video) H G ltem A B C D E F G H I I (Sync) Description : Total time Active display area including borders Active display area excluding borders Left / Top border Right / bottom border Blanking time Front porch Sync width Back porch The table below is required timings and technical description for the 34“ tube. (H = 620 mm, V = 465 mm standard size) 1 Mode No. 640 Resolution 480 & 60 Refresh Rate 39.722 Pixel timing +/- .5% 640 Horizontal visible 800 Horizontal total 16 Horizontal front porch 96 Horizontal sync 48 Horizontal back porch 160 Hor blanking time 480 Vertical visible 525 Vertical total 10 Vertical front porch 2 Vertical sync 33 Vertical back porch 45 Vertical blanking time Horizontal frequency 31.469 59.940 Vertical frequency Vertical sync polarity Hor sync polarity 25.2 Dot rate 2 640 480 72 31.746 640 832 16 40 136 192 480 520 1 3 36 40 37.861 72.809 31.2 3 720 400 70 35.311 720 900 18 108 54 180 400 449 12 2 35 49 31.467 70.082 + 28.3 4 640 480 66.6 33.06 640 864 64 64 96 224 480 525 3 3 39 45 35 66.667 + 30.204 5-2 5 800 600 60.317 25 800 1056 40 128 88 256 600 628 1 4 23 28 37.879 60.317 + + 40 6 800 600 56.25 27.8 800 1024 24 72 128 224 600 625 1 2 22 25 35.156 56.250 + + 35.97 7 640 480 85 36 640 832 56 56 80 192 480 509 1 3 22 26 43.27 85 36 8 800 600 72 50 800 1040 56 120 64 240 601 667 1 6 23 30 48.09 72 + + 50 9 1024 768 60 15.385 1024 1344 40 145 105 290 768 806 1 6 29 36 48.363 60 65 Hz n Sec Dots Dots Dots Dots Dots Dots Lines Lines Lines Lines Lines Lines KHz Hz TTL TTL MHz SPECIFICATION 2.4. VER1.0 Display performance requirements. The data of display performance are measured based on the following conditions unless otherwise specified. i. Heater voltage j. HV Operation ± 5 degree C 25± H : 0.00, V : 0.4± ± 0.05 Gauss 30 minutes minimum Nominal 120 Vac / 60 Hz ~ 220 Vac / 50 Hz With CRT screen facing east Distance from screen is 3.5m Test with full white pattern of mode 1 if not specified. Press reloads button to set Brightness to center point and adjust contrast control to 15 FL. ± 0.3Vdc 6.2± 31± ± 1KV 2.4.1 Maximum Resolution 1024 dots x 768 lines (non-interlace) 2.4.2 Horizontal size (Standard) Vertical size (Standard) 620± ± 8 mm (for mode 1〜 〜9) 465± ± 8 mm (for mode 1〜 〜9) 2.4.2.1 Horizontal size (max) Vertical size (max) Mode 1-6 ≧ Over-scan Mode 7-9 ≧ full-scan 2.4.3 Size thermal drift Within ± 8 mm (The size drift is being compared between the range of operating and ambient temperature.) 2.4.4 Size regulation 2.4.5 Maximum brightness level a. b. c. d. e. f. g. h. Ambient temperature Earth magnetic field : Warm up period Line input voltage : Unit facing direction Viewing distance Display mode Brightness condition 1. Less than 7 mm (MODE 1 → MODE 6) (The size regulation is being compared the size change between the max. and min. brightness level.) 2. Less than 7 mm (MODE 7 → MODE 9) (The size regulation is being compared the size change between the recall. and min. brightness level.) 24± ± 5 FL at the screen center. (While pressing reload button to set contrast and brightness control at max.) 85± ± 5 FL b. 100% center block white pattern (While pressing reload button to set contrast and brightness control at max.) c. Minimum brightness level With the contrast at min and brightness at central. Less than (ALL WHITE PATTERN) 5 FL. 0.5 FL± ± 0.3 FL. d. Raster background (With the contrast max, brightness at max and black signal) a. Full white pattern 2.4.6 Brightness uniformity (Test with five circle mosaic pattern and set the brightness level of center circle at 15FL.) Brightness (corner circle) >50% Brightness (center) 5-3 SPECIFICATION 2.4.7 2.4.8 VER1.0 Linearity (Test with cross-hatch pattern. H: 17 Line, V: 13 Line) Less than 15% for both H & V ≦15% ( X (max.) - X (min.)X100%)≦ X (max.) Distortions requirement a. Total Geometric distortion TOP & BOTTOM (See FIG. 1) LEFT & RIGHT b. Barrel (See FIG. 2) TOP & BOTTOM LEFT & RIGHT ≦8 mm ≦8 mm ≦6 mm ≦6 mm 2.4.9 Tilt (Raster Rotation) Less than ± 4 mm (The tilt is being Compared between the horizontal center line of the image with respect to that of the bezel.) 2.4.10 Misconvergence (See FIG. 5) Zone A: 1.0 mm ( 465 mm ) Zone B: 1.5 mm (Within the image area of 620 mm x 465 mm except zone A.) Zone C: 1.8 mm (Except zone A and B.) 2.4.11 Focus The individual dot and line of characters on the screen (with mode 1→ →mode 9) (Test should be clearly distinguishable. (Setting the Cut-off raster brightness level at H pattern.) with H character pattern.) 2.4.12 CRT quality The screen & faceplate blemishes requirement is defined based on CRT specification. 2.4.13 Color temperature (PATTERN=ALL WHITE PATTERN.) X : 0.270± ± 0.030 Y : 0.270± ± 0.030 2.4.14 Color tracking (Test full white pattern.) 2.4.15 Internal service controls : HV-ADJUST (31± ± 1KV) FBT SCREEN KNOB X : X0± 0.030 Y : Y0± 0.030 brightness=128,change contrast control range from 4.5 FL to max H-Center FBT FOCUS 5-4 DC B+ ADJUST (210± ± 1V) SPECIFICATION 2.4.16 VER1.0 External user controls : (With OSD Control) RGB : BRIGHTNESS H-PHASE R-GAIN AV,YCBCR: BRIGHTNESS R-GAIN COMMON : POWER INPUT CONTRAST V-SIZE PINCUSHION TRAPEZOID G-GAIN B-GAIN H-CENTER PARALLELOGRAM H-WIDTH ROTATION CONTRAST G-GAIN COLOR B-GAIN TINT SHARPNESS MUTE BASS DEGAUSS TREBLE WOOFER BALANCE FRONT PANEL FUNCTION KEY : VOLUME +/MENU +/- INPUT SELECT POWER SWITCH 3. MECHANICAL REQUIREMENTS 3.1. Unit dimension (with base) : Packaging dimension : W (866) x H (718) x D (583) mm W (1030) x H (870) x D (760) mm 3.2. Net weight of unit : 71 Kgs 4. Environmental requirements 4.1. Non-operating a. Ambient temperature b. Relative humidity c. Altitude 4.2. VOLUME RECALL DEGAUSS, - 15 degree C to 50 degree C (5 degree F to 122 degree F) 10% RH to 95% RH (non-condensing) 10,000 feet Operating a. Ambient temperature b. Relative humidity c. Altitude 0 degree C to 40 degree C (32 degree F to 104 degree F) 10% RH to 95% RH (non-condensing) 10,000 feet 5. Reliability requirement ± 5 degree C (77± ± 41 The MTBF needs 40000 hours (excluding tube) under operating at 25± degree F) ambient temperature also with the normal characters filled within the whole image screen. 6. Regulatory requirements 6.1. Safety requirement. The unit shall conform to the following safety regulatory standards. a. UL 1950 Safety of Information Technology Equipment Including Electrical Business Equipment b. CSA 22.2 Safety of Information Technology Equipment Including Electrical No. 950-M89 Business Equipment Safety of Information Technology Equipment Including Electrical c. TUV No. EN 60950 Business Equipment EN 60065 5-5 SPECIFICATION 6.2. X Radiation requirement. The unit shall conform to the following X-ray regulatory standards and must not emit more than 0.5 mR/H of ionizing radiation under normal operation or under a fault condition. a. DHHS 21 CFR 1020.10 6.3. Department of Health and Human Services Radiation Performance Standard; Title 21 CFR subject J, for Radiological Health (US) Emission requirements. The unit shall meet the EMI limits in all screen modes. For EMI testing, the unit must be filled with a screen pattern consisting of scrolling capital “H” characters also the brightness and contrast VR will be adjusted to max. level. a. FCC Class B 7. VER1.0 FCC part 15, Subpart J, Class B (US) POWER MANAGEMENT: Mode Normal Stand-by Power saving H-sync V-sync pulse pulse no pulse no pulse pulse no pulse no pulse pulse Video active no video Power dissipation normal power power off blanked less than 30 watts This monitor is Energy star compliant when used with a computer equipped with DPMS. Note: The power indicator LED color is green in normal state, red in stand-by and yellow in power saving state. Attachment: Internal reference specification. The following specifications are provided to Production Engineering and Quality Assurance Departments for factory internal control only. Item no. and contents of product specification 2.4.2 Horizontal size / vertical size 2.4.3 Size thermal drift 2.4.4 Size regulation 2.4.5 a. Max. brightness level (full white) b. Max. brightness level (100% center block white pattern) 2.4.6 Brightness uniformity 2.4.7 Linearity 2.4.8 TOP : BOTTOM : TOP : BOTTOM : a. Geometric distortion b. Barrel 2.4.9 2.4.10 2.4.11 2.3.13 Tilt (Raster Rotation) Misconvergence Focus Color temperature 2.3.14 Color tracking 7. POWER MANAGEMENT : a. Power saving Customer requirements ± 8 mm 620 / 465 mm± within 8 mm within 7 mm 24± ± 5 FL 85± ± 5 FL (MODE 1) greater than 50% H ≦ 15% V ≦ 15% within 8 mm within 8 mm within 6 mm within 6 mm within 4 mm within A:1.0, B:1.5, C: 1.8 Reference page 5 X : 0.270± ± 0.030 Y : 0.270± ± 0.030 X : X0± 0.030 Y : Y0± 0.030 PC < 30 watts 5-6 SPECIFICATION VER1.0 AV , YCBCR SECTION: (ACCORDING TO CTV RULES) :NTSC / PAL video signal compatibility: 1. Picture quality 1.1. Resolution (center) Contrast and brightness is adjusted so that the 25% gray bar is at cut off of CRT 300 lines min. 2. Linearity # formula: (max. - min.) / max. # ( AV ,YCBCR SECTION) Vertical Horizontal 10% 10% 13% max. 14% max. 3. Sound (tone & balance at central position) 3.1. Residual hum (at volume control max.) 3.2. Practical max. audio output (at 10% THD max.) 1.3VP-P 3.3. 1K Hz input 10W min. / 7 ohm Audio fidelity (400 Hz 0db, Corrected for emphasis characteristics) Woofer off Woofer off 100 Hz 10K Hz 1 dB -1 dB 3.4. Sound distortion (at 250mW 1K Hz) 4. Video and audio (full load) 4.1. Video signal output (input signal at 1.0 VP-P ± 0.2 VP-P) Audio signal output (input signal at 1.0 VP-P ± 0.2 VP-P) 4.2. 500uW max. 3 dB 3 dB 1% max. with LPF(15.734KHz) 1.0 VP-P ± 0.2 VP-P. 1.0 VP-P ± 0.2 VP-P. 5. Total Geometric Distortion ( AV ,YCBCR SECTION) 5.1. Pincushion(FIG. 4) Top-bottom Left-right *Pattern = crosshatch 5.2. 3% max. 3% max. Trapezoid (FIG. 3) Horizontal Vertical 3.0% max. 3.0% max. 5-7 SPECIFICATION VER1.0 FIG. 1 Total Geometric Distortion: FIG. 2 Barrel: Top Top barrel Right Left FIG. 3 Trapezoid: Left barrel Bottom B D C Right barrel Horizontal =(AD-BC) / (AD+BC)x100 Vertical =(AB-DC) / (AB+DC)x100 Bottom barrel FIG. 4 PINCUSHION: (AV) FIG.5 Misconvergence a1 A A Pattern = crosshatch bezel B a1 c1 C b1 D b1 Top-bottom=2(a1+b1)/(AC+BD)x100% Left-right =2(c1+d1)/(AB+CD)x100% 465 mm 465 m d1 c1 d1 Zone B 620 mm Zone C 5-8 EXPLODED VIEW VER 1.0 6-1 8 7 6 3 2 1 9V P5 D 4 V0 D113 9 10 9 10 11 8 7 6 5 4 3 1 2 IC102 M52055 ZD114 5.1B 9 C107 8 7 6 5 4 3 3 1 13 11 12 12 13 13 14 15 16 10 14 PI-3/10P R115 75 ZD115 5.1B 5 16 15 PI-1/10P G 10u C114 10u 14 RGB181 10u R116 27K C112 10u R114 75 C192A R102 180 .5W D R C104 15 SYNC ON GREEN 1/10P C105 C131 22 16V C190A J266 1.8K 2 G 4 AA1 AA2 AA3 D105 9V 5 8 B PI-5/10P 10u 12 2 C191A 7 C106 10u V 11 1 R111 2.2K H 6 H-SYNC H-SYNC OUT D108 R112 75 R190B R191B C121L Q120 R191A AA1 R191 R108 2.2K V-SYNC V-SYNC OUT Q121 R190A AA2 Q103 2SC1906Y R109 4.7K ZD112 5.1B C ZD113 5.1B R192B R120 1.2K R110 4.7K ZD111 5.1B RGB I/P Q102 2SC1906Y C R190 D109 P2 RGB TEST Q122 R192A AA3 R122 1.2K RGB183 15 C121 47u 35V 5 R192 10 14 Q104 2SC1906Y 4 9 13 3 B CV-5/6P P6 G CV-3/6P P6 R CV-1/6P D112 AA4 1 AA6 2 AA5 AA5 7 11 AA4 R123 1.2K 8 12 P6 D110 AA6 DB-7/9P 6 V1 P2 D111 R101 470 .25W V2' A1-1/3P H-SYNC 8 V-SYNC P2 B 8 9 9 10 10 11 13 P2 7 6 5 4 3 2 IC101 74LS125AN 1 Q101 DTC144 11 14 D106 12 B 12 R107 6.8K R106 22K 14 C122 47u 35V 13 ZD101 5C1 7 6 5 4 3 2 1 D107 PI-7/10P R133 4.7K 5V R131 4.7K P5 PI-9/10P 1 8 2 7 3 6 4 5 R149 180 .5W ZD001 5.1B D104 SYNC ON GREEN 4/8P STBY 12V P4 LINE1 IC691 10P R6B7 56 R199 100 R134 100 ZD125 5.1B IC106 AT24C21 P2 DDC-SCL P2 DDC-SDA ZD123 5.1B A A PLAG 1 SAMPO CO. ELECTRONIC RD2 (RGB.SCH) represent the critical component. 8 7 6 5 4 SME-32DL5(P) 3 2 Size C Document Number MONITOR RGB Date: Monday, November 19, 2001 Rev 0 Sheet 1 1 of 14 8 7 6 5 4 3 2 1 P5 Q031 R0C4 3.3K 38 SCL2 P2.2 37 7 SDA2 P2.1 36 IC002 M24C08 R037 3.3K 38 37 8 8 P2.0 36 ADC1 9 34 X001 12MHZ XTAL2 10 C012 12P 33 R079 2K R083 100 R045 33 P0.7 P0.0 18 25 IC006 80740AH 19 P0.6 P0.1 19 24 R067 39K R025 3.3K R0C1 2.2K OSD B P6 KH-4/9P P5 OSD BLANK P6 KH-8/9P P6 KH-1/9P P6 KH-9/9P P4 B2 7 8 14 13 14 13 12 12 7 8 9 10 11 R0A3 100 NC. P6 KH-7/9P P6 KH-2/9P TM-2/6P R/C P14 SCL' P4 SDA' P4 SDA' P6 KH-3/9P P8 A-2/7P TREBLE P8 A-1/7P BALANCE P8 A-5/7P VOLUME P8 A-6/7P R0A4 100 C C086 10u R' IC004 M62393P B P14 TM-4/6P P4 ROTATION R0C9 10K SB0 C075 .1 SFD C076 .1 SFD BB4 P11 B-2/8P BB5 P11 B-3/8P STBY 5V P11 B-4/8P SUSPWND P5 SUSPEND WOOFER P8 A1-2/3P SB0 P3 SB0 SB1 P3 SB1 LEFT MASK SB1 Q001 BB6 20 VIDEO MUTE P0.5 P0.2 20 23 23 R027 4.7K LEFT MASK R073 4.7K 21 HOR BLANKING P0.4 P0.3 21 22 D009 D035 R0A2 33K MA-6/8P RIGHT MASK MA-5/8P P3 B1 H-SYNC OUT P4 H-SYNC' V-SYNC OUT P4 V-SYNC' 22 R074 4.7K BB6 BB3 STBY 5V BB1 BB2 Q034 DTC144 AUDIO MUTE MUTE P8 A-4/7P VIDEO MUTE VIDEO MUTE P4 H-BLK P5 HOR BLANKING P6 HS-1/7P P6 HS-4/7P AUDIO MUTE SYNC ON GREEN 10/10P CLAMP DET P12 HOR BLANKING C080 .01 A V0 V1 V2 CS0 CS1 CS2 CS3 SB0 SB1 TS NC. TV AV1 AV2 YCbCr 0 1 0 1 0 0 1 1 1 1 1 1 YPbPr RGB 1 00 1 10 0 0 0 0 0 0 0 0 0 0 0 0 POWERON POWER SAVING OFF 0 0 0 0 1 1 0 1 0 0 C SCL' BASS SEV R0E1 1K R071 330 24 KH-5/9P B R0B1 10K C067 .1 25 P6 C066 .1 SFD R069 4.7K R066 6.8K KH-6/9P OSD G C050 .1 SFD R099 10K R0E2 10K OUT R070 3.3K R024 10K 9 10 CR01 47u 16V 2.2K C049 470 10V CS0 26 C073 .1 SFD VCC 18 9 CS1 26 27 2.2K 9 SCL _____ RESET VDD CS2 Q002 __________ V-SYNC OUT 17 27 VDD C077 .01 P11 B-5/8P WOOFER R057 1K R0E3 10K CS3 DEGAUSS 10 10 VFLB C068 470P SDA P12 Q003 VCC R022 10K P12 SYNC ON GREEN 9/10P DAC0 RIGHT MASK R056 10K 28 D005 C059 .01 V-POL 17 V-SYNC IN 16 CS2 PWM C063 .1 SFD A05 R020 3.9K V-SYNC OUT 28 29 C0C1 .1 SFD R034 47K R0C7 1K A04 SYNC ON GREEN 8/10P C037 .1 SFD C062 .1 SFD A06 BB3 SUSPEND A03 BB2 P11 30 A07 P11 DAC1 CS1 P5 P6 R084 10K R094 10K C061 .1 SFD R060 10K A02 B-8/8P BB1 R0C6 10K A08 B-7/8P P11 R019 1.8K R026 56K SCL3 15 11 11 R0A7 10K C060 .1 SFD 31 C035 .1 SFD 16 R092 10K B-6/8P 15 P5 OSD R 12 RP97 10K STBY 5V C034 1000 10V C010 .012 P1 V-SYNC 32 VL Vref B ZD102 5.1V 29 12 R0A8 10K U2 D001 N DAC2 CS0 C051 330P BB4 C033 .01 A01 SCL3 14 3.3K R0C2 100 __________ H-SYNC OUT 14 P1.5 R085 13 C020 1000P 1.5K BB5 470 R050 10K Vref R016 C021 100P C014 N R0E4 JUMP 30 13 TUNER R0A1 150K U1 Vref H-SYNC OUT AV BOARD DB-6/9P DAC3 D DB-3/9P P5 C052 330P IC003 MC141541P R090 GND R015 470 AV BOARD DB-4/9P H-SYNC IN 13 R086 14 B 8 SCL 8 R088 10K ZD001 5.1V AV BOARD DB-2/9P H-POL 13 P1 H-SYNC 31 DB-5/9P P3 R028 1K C031 470P TS * 2.2K G 6 SS 6 7 SDA 7 VSS 12 WM2-17/17P C053 330P 14 FBKG R095 5.6K STBY 5V VSS 12 R014 1K 32 R087 15 ZD007 5.1V R051 1K 11 15 5 HFLB 5 R0B6 100 11 11 RGB TEST P4,5 R081 3.9K VDD C013 100 16V 16 R 4 VDD 4 R080 1K R082 100 R089 10K 34 C064 .1 SFD 16 C046 33P 35 VDD C099 .01 V2 P9 VSS C045 33P C047 .047 MLO ZD005 5.1V R043 10K ADC0 10 R0B4 3.9K 1 VSS 1 3 RP 3 R0B5 100 DDC-SDA C018 6800P 35 XTAL1 9 C011 12P R040 100 R041 10K DDC-SCL C044 .01 Q010 DTC144 Q012 DTC144 R039 3.3K R042 100 C043 .1 SFD 2 VCO 2 39 ____ INT1 R013 10K AV BOARD 1 SDA1/SDA P2.3 AV BOARD SCL 1 6 39 C042 100 10V VSS 20 5 SCL1/SCL P2.4 DB-7/9P P1 20 7 C015 .1 SFD C R0C3 100 40 4 SDA C017 6800P R012 330 DEGAUSS 3 A2 5 2 6 CS3 C029 .1 SFD R033 100 C030 1u 2 5 4 DB-8/9P 41 19 FB103 CORA1021 40 SDA L831 10uH 3 C022 .1 SFD 6 R078 470K STBY 5V B-1/8P 4 R011 330 CS2 P11 SDA3 P2.5 41 R091 6.8K 3 C023 .1 SFD 3 PWM9 P2.6 R044 100 R010 560 CS1 2 J252 18 C024 .1 SFD R0A9 100K 19 CS0 3 R008 1.8K P1,4,5 2 18 C025 .1 SFD A1 4 R036 2.2K TEST 7 SCL 2 R007 15K Q035 V2 R098 3.3K 42 4 A3 42 17 R004 220 C028 .1 SFD A3 P1 PWM8 17 A2 P87C380 P2.7 R038 100 V1 A2 V2 H-SIZE J198 5 FS P1 D038 1 A0 5 P5 C026 .1 SFD VCC 16 FS IC001 1 V0 R097 3.9K SDA3 1 16 C001 470 16V AV BOARD 75 V2 6 R001 220 TUNER CARD TM-1/5P D 8 R0B2 5.6K R061 1K 6 C002 .01 R075 39K P1 DDC-SCL V1 RGB TEST 15 P1 AV BOARD R064 15 TM-3/6P A2 R002 3.3K TUNER CARD (TS) DDC-SDA L001 12uH R003 10K STBY 5V FS A-7/7P STBY 5V A3 P7 V0 W/O TUNER NTSC PAL SECAM 5V 2.5V 0V 0V A PAGE 2 SAMPO CO. ELECTRONIC RD2 (CPU.SCH) 31K 35K 38K 43K 48K 8 7 0 1 1 1 1 6 0 0 1 1 1 0 0 0 1 1 SME-32DL5(P) 0 0 0 1 1 5 4 3 2 Size C Document Number CPU Date: Monday, November 19, 2001 Rev 0 Sheet 2 1 of 14 8 7 6 5 4 3 2 1 DC 150V SB1 P7 D-2/2P P7 D-1/2P P2 IC713 1 4 3 D Q711 DTC144 R708 6.8K C709 330 40OV C710 .01 AC400V 2 FB703 CORA1021 C719 10u D PC817C T701 RCVTP1381 12 R707 180K .25W R711 180K .25W R714 270K .25W R712 180K .25W R715 270K .25W C711 2.2 250V R718 68K 1W R716 82K 1W 4 R704 150K .25W ZD711 12V HZA1 R721 100K R717 82K 1W R719 R720 100K C P4 19V P13 DB-1/10P C758 1000u 16,13 6 68 .5W C724 N C760 2200 16V C713 .1u C707 D756 HER303 PR 15 P1,2,4,5 13V L762 CHO-1103 FB712 CORA1037 FB702 CORA1004 4700P AC400V R756 150K .5W C725 N 8 C706 R755 4.7K .5W MR FB751 CORA1021 L 4700P AC400V 205V D712 FR103 C714 47 35V C712 2.2u P4,5 S D711 UR1J Q712 U-1/5P C757 47 250V C756 100 250V D754 UR1K D755 HER303 PR 17 P10 110uH R754 4.7K .5W MR 2 R703 150K .25W CHO-1103 C755 100P 1KV R706 220K .25W BR701 GBU6J PR L752 D753 BY329X-1200 PR C L S D757 FR304 FB711 CORA1021 T703 RCILF1080 6.3V 14 Q713 STW11NB80 PR C764 470 16V R748 .18 1W C765 100 10V P2 6.3V P6 PO-2/4P P6 PO-1/4P D TH701 VSH20S050M NTC L757 CHO-1103 D759 FR203 11 P4,5 TH702 VSQDG2R90Q C766 1000u R7A8 3.9 .5W PTC M F701 3.15A/S 250V C7A1 1500P 2KV C705 .01 AC400V R722 22 ZD712 18V HZ-2 2200P AC400V 6 5 R733 68K 4 C718 1500P PE 191V 191V R731 267KF .25W Q731 3 2 C715 10u R7A2 1.8K .25W ZD731 12V HZA1 IC711 KA3842A R702 10K FB701 CORA1004 R7A3 10KF ZD7A1 6.8V D7A1 1N4001 R701 1K 1 T702 RCILF1088 L C703 8 Q701 C702 2200P AC400V 7 B R7A4 750 Q7A1 2SC3467 R7A7 56K .25W C726 .01 ML C7A2 10 250V R7A5 267F Q7A3 2SA1470 R723 1.2K .47 AC250V L751 CHO-1103 Q7A2 2SC2688 R724 .22 3W D701 C704 R7A6 15K 1W R725 .27 2W 28V C767 N R753 10K .25W D713 RL701 RRLYD1080-1PDGA 110uH P6 PO-4/4P P6 PO-3/4P B R732 14K .25W C701 C717 1500P ML R727 18K .47 AC250V VZ701 V300K14 C716 4700P R726 30.1KF MR C799 .01 1 R743 100K .25W R734 1.5K .25W R735 4.7K .25W IC712 4 D714 R729 3 SO701 10K .25W SOCP1042 C727 4.7u ZD713 5V HZC1 PC817C R728 27K R737 100K .25W C736 1000P 2 C731 .1 SFD C720 N VR731 500B H6 R736 39K R P2 DEGAUSS 12V A B1 SB0 R739 22K C734 N K C732 C733 A P5 4700P AC400V P2 4700P AC400V R738 2K C737 2200P 100V Q732 R742 24K D731 TL431CZ IC731 R740 3.3K C735 4.7u R741 39K A P2 PAGE 3 SAMPO CO. ELECTRONIC RD2 (POWER1.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number MAIN POWER Date: Monday, November 19, 2001 Rev Sheet 3 1 of 14 8 6 5 P3 4 .22 RD01 5.6K DD01 R6X1 100 R501 5.6KF IC691 9 8 R515 10K Q502 C512 .022 SBD C510 .01 R518 22K R507 2W O-4/4P V-YOKE O-3/4P R502 22 .5W C507 100 35V 16 V-YOKE C504 .22 ML R520 6.8K 16 15 14 15 14 13 13 12 12 11 11 10 9 10 9 8 7 8 7 6 6 5 5 4 3 3 4 2 2 PWM O/P Q501 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 1 1 H-DRV R506 68K 1u C503 10u C501 .1 SFD X-RAY R517 22K 9 7 8 6 7 4 5 6 1 20 R521 820K 21 R695 25KF 22 R692 2.2K C697 .12 63V D Q503 DTC144 C505 R503 1 2W NMT TDA4854 C6C2 10u TUNER CARD P1 P6,12 CLAMP CLAMP PULSE & V-BLANKING PULSE P5 C6D7 220 16V C R696 4.7K C6C3 8200P 100V D615 1N4001 R698 680 R697 2.2K 12V P5 12V D620 RGP15G C699 1000P ZD607 P2 H-SYNC' P5 E2 19V R651 10K 19V P2 ROTATION R6G6 47 1W R6A4 6.8K R6C5 47K ROTATION COIL FB604 CORA1021 C6A3 470 16V 12V R6A3 332KF C681 N R6A5 820 R622 22K Q692 2SA950Y R6A3 2K DC SIGNAL(FBT PIN 12) C651 .01 C6A4 R684 330 H-DRV D616 C655 NP Q622 R660 10 R658 47K Q621 DTC144 P5 P2 H-PULSE Q623 R682 34.8KF R6K7 2.2 8 1 R699 3 + - C644 100P C645 10u C643 .033 ML C654 2200P MLO R6G7 820K 6 3 5 4 R6D4 560K .5W Q6C7 2SC1213C R6E4 100 2 C6C6 .01 2KV C6C9 10u Q6C8 2SA673C R6G3 270K D694 Q6D2 R6H1 1.8K R6H0 22K Q6D9 1 6 C6D0 1u Q6D3 R6G4 680K 3 T604 TRN-1059 R6E9 3.3K 2 R6A8 3.3M R6F1 100 FB6C4 N FB6C3 N C6D3 .1u C6E4 270P 5mH D6C5 SF16 R6F6 4.7K .25W ZD6C2 15V RDEB3 R6A9 33K 15 C6D6 2.2 250V MP 5 7 487F P6 FOCUS CRT P6 SCREEN P6 HS-3/7P 2KV 16 FV 9 6 R6G5 1K .5W 4 R6G0 402F CRT SG601 QSPG-1011-1 R6G2 15KJ R6G1 C6A6 33 16V D.F.C. 1000P/15KV L6C1 CHO-1110 C6D4 47 250V R6T2 1.5 .25W 4 X-RAY PROTECTION A C6T2 220 16V 14 C650 2700P 400V PP ZD6C1 20V C6A9 .01 208V C6E5 100P B 12 H.V.R. 4.7K/1W HV C6T1 100 16V 13 Q6D4 IRF740 R6G9 22K C6D2 3900P 1.6KV PP R6E8 100K TDA4853 PIN 32 P5 P6 BLEEDER 600M 1000:1 H.V.C. 6000P/35KV 2 L605 68uH DYNAMIC FOCUS IN Q6T1 DTC144 FBT150 R6E5 100 FB602 CORA1021 P3 T6C2 D6C1 RGP02 Q6C9 2SK1358 R6E6 22 R6D6 2.4K P5 C6E3 1000P 1KV D6C2 RGP02 1 R6D2 27K R6D5 56K 1 7 4 120K C653 .01 IC6C1 NJM2904D 33K 2 REGULATION 48K D6C6 208V IC632A LM358 R687 5V P5 SOFT-START CS3 R659 1K R6D3 560K .5W 12V R688 100K 8 R686 75K Q6C4 2SC4152 R6K8 10K D6K1 C646 100 16V B HV PROTECT R6D1 180K .5W P5 R683 10K V2 .056 ML R6A7 56K DYNAMIC FOCUS OUT C Q693 2SC2120Y Q691 ROTATION VOLTAGE H-DRV L691 RCILQ1014-1 RO 1 R6C4 39K SIDEPIN P5 2 H.V. ADJ. FB603 CORA1021 HS-6/7P P5 R6A6 10 2W C6C1 47 63V ZD606 5.1V VR691 100K R6A2 100KF D1 R6C9 1/ .5W R6M1 470 C6A0 470 16V P2 V-SYNC' TM-1/8P P5 P5 H-FLYBACK E1 V2' C511 .01 220 A1 P5 R516 2.2K R508 120K C696 .1 63V V2' IC501 TDA8351 QD01 DTC144 C693 .22 63V ML 24 R690 1K 29 32 R694 5.6K R6H4 330 R691 4.7KF 30 R689 4.7K C692 .01 100V C691 .012 ML 31 Q696 DTC144 B2 13V RD02 6.8K R6X2 100 C694 8200P 100V 23 Q695 DTC144 P5 9V HS-7/7P VIDEO MUTE 28V R693 3.3K P5 D610(-) R6B6 820 25 P2-1 V2 C6B1 .01 Q694 DTC144 26 SDA' 27 SCL' P2-1 28 P2-1 SCL' 5 28V SDA' 3 P3 SCL' P6 D641 C530 V2' 4 13V 2 B2 SDA' H-BLK 3 28V P2 P3 1 13V D503 VIDEO MUTE 2 H-BLK B2 1 5V 17 P2 2 2W 19 5V 3 R519 2.2K R505 19V P5 18 19V D 7 C6D9 22u D6C7 RGP10D 8 R6F9 .18 1W A ABL C6E0 4.7 200V NP PAGE 4 SAMPO CO. ELECTRONIC RD2 (HV.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number H.V.&VER. Date: Monday, November 19, 2001 Rev 0 Sheet 4 1 of 14 8 7 R791 1 .5W VI VO 5V Q613 BD140 R6B1 1K .25W 1 VO GND VI 3 2 L603 CHOM1077 VO GND VI C605 .82 100V MP C796 100 16V IC792 MC7805ACT D614 P4 H-DRV C602 680P 500V R602 5.6K 28V R608 56 3W R606 6.8K .5W R609 68 3W R6B8 22K 6 C687 .056 400V PP C604 100 63V 0.37mH C6I1 4.7u CL01 0.047uf CL02 0.027uf RL04 560 1W D643 Q6I3 2SD667AC C685 PP .068 400V R6D8 Q629 IRF740 100K .25W R6J3 18K C683 22P 500V Q625 KSP42 3 C609 1.5 400V MP RL01 100K D611 R6I5 560 T6C1 TRNF1006 1 400V PP FOUCS CONVERTER 5 6 LL01 RCHO-1121 RL03 560 1W 3 2 12V HZC1 C684 6800P 500V R6I6 5.6K QL01 C6I3 220 16V 2SK2866 DL02 R6H9 12K DL01 H-YOKE RLYD1088 Q6D1 2SC1318R 208V C610 .12 400V PP IRF740 PR Q606 R615 120K .5W R616 33K R642 100K .25W D604 ZD603 12V HZC1 Q605 2SC1318R C611 .01 400V PP R643 100K R617 120K .5W R618 33K IRF740 Q607 KSP42 C613 22P 500V C680 100u 16V R6H8 82K R627 82K Q608 C617 22P 500V ZD604 12V HZC1 R628 82K Q609 KSP42 C612 6800P 500V R614 100K D621 R629 82K R630 82K C614 6800P 500V Q624 2SC1318R R6K1 10K R6K2 33K V2 D1 P3 SUSPEND Q634 DTC144 D644 9 R6G7 82K A2 C631 220P R632 5.6K R6H6 33K R6K9 15K 3.3K D610 D611 8 7 R654 150K R653 47K C640 .1 ML D661 C622 .01 C639 2.2u 5 7 IC632 LM358N B C670 1u R669 3.3K R663 10K 6 2 1 L661 CHO-1139 C675 270P 5mH 4 R673 4.7K TRN-1059 C671 100 200V D664 SF16 Q663 C668 100P R675 68.1KF MR R666 22K R667 22K R674 82.5KF .25W C672 .012 200V PP R652 4.7K R676 4.02KF MR Q661 C665 3900P 6 + 3 1 2 R662 120K R656 1K P2 HOR BLANKING 3 8 7 7 8 D618 C664 .1 SFD B T603 Q664 C667 100 25V C663 4700P C662 2200P 100V Q665 IRF740 PR ZD661 15V RDEB3 R668 1.8K IC661 UC3843 R634 1.8K C674 .1 SFD R664 10 Vcc Q631 R670 39K A C666 .1 SFD VFB R645 C638 2.2 16V ZD608 9.1EB D631 C630 33P Q632 MPS3646 C647 .1 63V P2 H-SIZE C661 .1 SFD D6C6 C625 1000P 100V PP R638 10K R672 100 R661 59KF R636 560 .5W R633 3.3K 9 10 B2 6 5 5 Q1 10 11 11 12 12 13 13 4 IC631 74HC221 4 14 3 3 Q1 D619 P2 R6H5 2.7K R631 47K R637 P1 R650 6.8KF PP P4 12K 12V R635 10K 6 R6F4 12KF 14 15 2 1 2 B1 1 A1 15 16 16 Vcc 12V D617 C615 100u 10V CLR C637 470 16V R655 68K PI-010/10P R681 4.7K D663 H-PULSE HS-2/7P U-5/5P C669 .22 400V PP 5 Q635 C635 680P 200V E2 P10 208V 4 R6F5 22K P4 8.2KF C634 2.2u R647 56K 6 R639 12KF R639A 9.09K R641 47K C C649 8200P 630V PP 5V R6F3 C655 470 16V O-2/4P R6K3 .56 3W P2 V2' E1 C648 .01 1.6KV MP CL05 2SK2866 CL04 208V B U-4/5P P4 QL02 2 R613 R6E3 39K U-2/5P P10 RL02 100K R6I9 2.2K 68K C6A1 47P P10 RL602 RLYD1085 LINEAR P3 R639B 2.7K DYNAMIC FOCUS OUT DL03 SF16 Y Q615 HS-7/7P O-1/4P P4 10 1 L601 CILL1074 V2 R685 47K H-FLIBACK SF16 RL601 D622 P4 HS-5/7P P4 R6C1 3.9K C6I5 4.7u CL03 0.033uf DL04 ZD611 R6C7 33K .5W R6E1 82K L602 CILL1075 1 RL604 RLYD1088 R626 68K P6 P6 R6J1 2.2K C6E2 .047 R6I4 56K R6C8 120K .5W 208V L604 CHO-1132 V2" CS1 5V D793 Q6I4 C6I2 5600P Q6I2 2SB716 R6I0 3.9 2W C623 3300P 1600V PP D630 SUF30J RLYD1088 P2 C6I6 33u /2W D609 SUF30J D640 R625 12K R605 68K C608 1000P R600 RL603 C686 22P 500V R6J4 2.2K C6I7 .068 3W R6D9 82K Q611 2SC1318R C603 1u 208V 9V P1,4 D R6I8 820 R623 3.3K Q6I1 2SB861WC 10/ NMT 12V R604 68K R612 560 5W NLQ C682 6800P 500V Q630 KSP42 R6I7 15K D642 ZD601 5.1V LINEAR RV81 68K Q602 P2 12V P1,4 H-DRV B+ ZD612 12V HZC1 R6D7 82K U P2 R6I1 4.7/ 3W NMT C607 1000P 500V Q620 IRF740 PR R6C3 33K R6C6 82K P2 C624 3300P R6I3 8.2K ZD605 5.1V C660 1000P R6I2 L6I1 CHO-1129 C606 8200P 1.6KV MP R6C2 100K .25W R6F7 120K .5W Q603 2SA1020Y PINCHSHION COIL 560 C608 .22 400V MP D602 MUR115 . 4 3 . R603 39 3W R621 220 7 R619 5.6K C6E1 100P D607 1 D603 FMQG5FMS R610A 47 .25W 1 D601 FR104 22K OSD BLANK U-3/5P P3,4 H-YOKE R610 .56 3W R607 P2 R6B2 1K .25W S T601 RTRND1060 Q601 2SC36210 D605 RGP30G FB601 3 C743 100 16V R620 6.8K Q604 2SC5422 3mH 2 R601 680 Q612 BD139 C6E6 100P T602 RTRN-1060 C745 100 16V R794 1 .25W R6J2 22K R6J0 2.2K Q6I5 14 3 2 C621 100 25V C6E8 680P D606 RGP30G C620 100 25V VR601 5KB H6 R6B3 33 2W PR 5V C601 22u P10 3 C742 100 16V IC793 NJM7809FA 1 CS0 C6I4 33 25V 9V 1 C744 100 16V V2 1 12V GND P3 R793 1 1W CS3 2 12V IC791 LM2940CT12 PR C741 100 16V CS2 3 28V D C 4 P3 2 13V 5 P4 SIDEPIN 28V 6 P4 DYNAMIC FOCUS IN PI 10/10P HV PROTECT SOFT-START P4 QD01(+) P6 HS-2/7P P2 FS P4 SOFT-START P4 HV PROTECT P4 H-PULSE FS A PAGE 5 SAMPO CO. ELECTRONIC RD2 (DEF.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number H. DEF. & SIDEPIN & RASTER CENTER Date: Monday, November 19, 2001 Rev 0 Sheet 5 1 of 14 8 7 6 5 4 3 2 1 R950 15K/2W R951 C922 .01/500V 15K/2W R952 15K/2W D R953 10K D R949 10 .25W L902 47uH PH Q909 L971 4.7uH NH 2SC3790E R944 180K .25W P2 KH-7/9P R901 P2 KH-8/9P IC901 TDA4885 R905 100 1 KH-6/9P P2 OSD R P2 OSD G R906 100 2 R907 100 10K 3 P2 R908 100 10K OSD B P1 R914 2.2K P1 CV-4/6P P1 CV-6/6P P1 CV-5/6P C904 .01 B 8 R915 10 68 11 R917 100 R918 100 H-BLK P4,5 HS-7/7P R919 100 R920 220 B P2 KH-3/9P SDA' P2 R921 220 SCL' 30 28 6 27 7 26 8 G 25 9 24 10 23 11 22 12 12 21 31 P4 Q907 R961 220 2SC3955E R940 4.7K 29 C913 100 16V 28 C915 .01 R941 68 R942 150 15K/2W R974 15K/2W R975 L972 47uH PH C914 470P 26 Q971 D909 1SS83 FB902 CORA1021 R938 5.76KF R939 68 R976 10 .25W 2SC3790E R943 12 R937 180K .25W 27 C925 .01 Q905 C911 100 16V 23 Q904 R935 150 R931 180K .25W 21 13 13 B 20 15 14 19 15 18 16 SCL 16 C908 100 16V 18 L974 47uH PH R936 12 17 R926 4.7K C907 .01 5 7 FOCUS VR901 20M R984 10 .25W H.V. SCREEN R986 27 .25W D901 R993 100M .25W L975 4.7uH NH R985 27 .25W D902 Q903 H.V. SG975 1.5KV 1010 C973 .01 2KV G2 KBE G R987 R988 6.8K 47 .5W SG973 300V 1009 B VCNCP0102 Q974 2SA1480E Q902 17 4 Q973 2SC3790E R930 68 C910 100 16V C926 .01 8 6 11 10 9 HV 15K/2W R983 19 ABL R924 120 R957 10K 2SC3955E 20 B SG972 300V 1009 GND3 D910 1SS83 FB903 CORA1021 14 G 15K/2W C912 470P 22 R R980 47 .5W C 15K/2W R982 R962 220 R933 4.7K CRT VBM81AHM50X01 R979 6.8K R981 2SA1480E R934 68 24 L973 4.7uH NH R978 27 .25W D904 D903 R977 27 .25W Q972 25 SG971 300V 1009 R973 R954 10K C916 100 16V R971 47 .5W 15K/2W Q906 30 R925 18K HS-3/7P R946 68 C924 .22 R932 5.76KF SDA KH-2/9P R 5 B R916 2.2K R922 120 31 FB901 CORA1021 32 Q908 2SA1480E 2SC3955E 9 KFD 32 29 G R913 68 P1 CV-2/6P C902 100 16V R912 120 R945 5.76KF 4 R 7 C903 KFD .01 G 6 L901 10uH PH R911 2.2K CV-3/6P 5 R910 68 C901 .01 KFD R P1 CV-1/6P R909 120 10K CLAMP 4 B R904 P4 HS-6/7P 3 G R903 KH-4/9P 2 R R902 KH-5/9P 1 FBL 10K R972 6.8K R947 27 .25W D906 P2 KH-1/9P R948 27 .25W D911 1SS83 D905 NC. P2 KH-9/9P C C971 10 250V R927 68 FB905 CORA1033 R963 220 C909 470P R928 150 C906 10u R929 6.8 C921 .01 HS-5/7P HS-4/7P P5 8V P2 NC. R955 33K R989 1K .25W D908 D907 P2 HS-2/7P Q901 VIDEO MUTE P2 HS-1/7P C905 .01 C917 47 25V R990 2.2M C972 2.2 250V 2SC2482 R956 15K Q910 P3 PO-3/4P R923 15K R991 56K .5W D971 1N4002 P3 PO-1/4P P3 PO-4/4P FB904 CORA1033 SG974 300V 1009 225V A A P3 PO-2/4P 6.3V P4 HV P4 FOCUS P4 SCREEN PAGE 6 SAMPO CO. ELECTRONIC R&D2 (CRT.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number CRT PWB Date: Monday, November 19, 2001 Rev 0 Sheet 6 1 of 14 8 7 6 5 4 3 2 1 C788 470P 2KV T781 D R787 15K 2W D788 UR1K 3 9 C780 22u 400v C785 .018 630V R786 4.7 .25W R790 15 1W D790 SF16 FB785 S-2 FB782 L 30V +/-3V 1A 30V 12V .25A 12V 5V .1A 5V R790 15 1W C789 3300u 1 10 IC781 78L05 1 VI FB783 S-2 VO 3 C795 100 16V 5 2 D786 FR103 7 GND 1 D D789 SUF30J FB784 S-2 D C781 22 25V R785 3.3K 11 C791 1000P 1KV FB781 M C 4 1 2 2 3 3 4 4 5 5 12 3 C782 4700P ML 1 C C792 100 25V 5 FB787 S-2 C787 4700P C786 4700P FB786 S-2 R795 4.7K .5W MR IC717 1 4 4 C798 1000P C790 .1 IC716 VIPER100 C784 .1 C783 .068u 3 ZD781 3.9V 2 2 B R IC782 TL431 R784 1K R794 39K K ML B R797 22K PC817 A C799 2200P R792 4.7K Primary GND layout 1 5 4 3 FB786 2 A A PAGE 7 SAMPO CO.ELECTRONIC RD2 (POWER.SCH) SME-32DL5(P) 8 7 6 5 4 3 Size B Document Number POWER Date: Monday, November 19, 2001 2 Rev 0 Sheet 7 of 1 14 8 7 6 5 4 3 2 1 F301 2A/F 250V 30V/1.1A P7 GND P2 R P2 TREBLE P2 BASS P9 12V R305 D C367 2200P 30V/1.1A IC311 TDA2616 PR Q305 N C351 .33u C374 2200P C376 2200u GND C386 R399 2.7K A-3/7P - 8 - 4 CH1 9 + 6 CH2 R 10 P9 STBY 5V 11 P9 GND 12 C310 .047 ML R318 33K C387 .47u 50V C301 4.7u C318 2.2u J735 C C304 .47u R3A0 1.8K C302 .56u C366 2200P C385 100 25V R344 1K R387 .22 2W C324 1u R386 .22 2W LO R313 47K C338 .1 ML C339 .47u RSPKKS085-18WN R-LOW SPEAKER C341 .47u D302 R388 1.8K C383 4.7 25V R341 12K L-HI SPEAKER C340 .1 ML D303 C357 .022 ML D304 R389 1.8K R-HI RSPKER086-18TN SPEAKER C384 4.7 25V D305 R324 8.2K R351 8.2K R333 10K R332 3.9K R350 3.9K 7 8 R352 8.2K C331 56P R367 8.2K R377 33K 5 1 2 R355 3.9K C346 470 16V R362 10K 7 R353 4.7K R375 CC1 1 1 2 2 3 3 4 4 LDU 8 7 6 C328 .33u C329 .22u R374 47K 10K R360 4.7K 8 7 6 5 8 7 6 5 R361 R358 2.7K R371 560K 8 7 6 5 47K R368 33K R379 56K R378 150K 11 4.7K D301 Q302 DTC144 C332 10u R354 5 R315 47K R348 6.8K R330 3.9K R322 3.9K C315 10 16V NP 6 5 4 R335 8.2K R337 3.9K R331 3.9K R356 8.2K 1 2 R346 6.8K R334 8.2K R336 3.9K 8 9 10 11 12 R325 8.2K 13 14 12K 3 4 1 2 3 4 1 2 3 4 R326 R327 3.9K B R359 4.7K 3 7 6 C347 .12 ML R349 4.7K IC303 NJM4558D 6 R347 1K C345 .12 ML B C327 56P IC308 NJM4558D 8 7 6 IC304 NJM4558D IC305 NJM4558D 5 8 R329 10K R345 1K 5 4 3 2 1 IC302 MC14066BCP 7 5 R328 10K 8 7 6 5 R323 12K 6 R304 1K R316 47K R317 47K R340 12K R339 12K R338 12K R398 8.2 .25W C358 1000 35V 1 4 L-LOW SPEAKER C313 10 16V NP C C359 1000 35V 8200P ML BALANCE P2 C356 .022 ML C375 2200P R394 15K C303 A-5/7P L 5 A-7/7P + 3 R397 8.2 .25W C352 .33u J7A3 VOLUME P2 1 Q306 N 9 A-6/7P C377 N 7 R392 2.2K N R393 15K 1 IN2 2 C365 47 16V R391 2.2K N 2 20 19 VCC IN1 18 3 3 4 5 OUT2 5 6 BAL 7 9 10 8 VOL C311 10u 7 LUD 6 8 J7A2 R396 1.8K C368 1000 16V C388 .47u 50V R3C8 2.7K IC301 TA8184P R314 47K R308 22K REF C312 10u 5 18 17 4 17 R312 47K 3 R390 56K C364 N N 4 STBY 12V R309 82K 2 R3A2 8.2K R3A1 1.8K 16 P9 C309 10u OUT1 A1-1/3P J7A1 R307 22K R301 4.7K C306 8200P ML C308 4.7u 14 C321 47 16V 1 WOOFER R310 1K Q303 CC P2 C307 .56u C323 1u 16 R303 22K R3A3 8.2K C322 1u R311 1K R3A7 100K R3A6 22K N 15 R3A4 390K R302 2.2 1W A1-2/3P Q304 DTC144 C305 .47u 4.7K RIP A-2/7P A1-3/3P P2 MUTE 13 A-1/7P L TRBL SF-1/3P P2 12 SF-2/3P D MUTE BASS SF-3/3P P2 11 A-4/7P DEF 30V R306 1K WOOFER C334 .22u Q301 DTC144 D307 C343 .022 ML IC310 NJM2904D R L R366 4.7K 5 R-BACK 6 R376 1K A R384 56K 4 1 2 R381 33K 10 R383 1K 9 R370 3.3K R357 2.7K R385 33K IC309 NJM4558D R364 10K 1 2 3 4 1 3 2 R372 3.9K IC307 NJM4558D D308 R380 2.2K 4 1 2 3 R373 3.9K D309 IC306 NJM4558D 56K D316 3 D306 R382 4 1 2 3 4 L-BACK R343 33K 7 R342 56K 12V 8 R365 4.7K C333 .33u GND 9 9 A VOL-OUT R363 4.7K 10 R369 10K 10 C342 10u VOL-IN 11 H-VOL-4 12 12 PAGE 8 H-VOL-2 SAMPO CO. ELECTRONIC RD2 (AUDIO.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number AUDIO Date: Monday, November 19, 2001 Rev 0 Sheet 8 1 of 14 8 7 6 5 3 2 1 CLAMP SM-10/10P V-OUT SM-7/10P H-OUT SM-6/10P GND SM-5/10P V-POL SM-9/10P H-POL SM-8/10P RS01 39 1W B+ SM-4/10P 4 RS02 180 .5W CS01 220 16V ZS01 5V ZS02 5V RS03 3.9K CS02 220 16V RS04 4.7K RS06 3.3K RS05 820 RS31 5.6K D RS08 15K RS09 39K CS03 N DS06 CS05 220P CS23 180P 11 QS06 RS11 5.6K QS01 DTC144 10 9 CS11 10 10 9 8 CS10 4.7 8 7 7 6 6 5 4 5 4 3 3 2 2 CS20 100 16V RS35 3.3K ICS01 M52346SP 1 DS07 RS32 5.6K 11 12 12 13 13 14 14 15 15 16 16 17 17 18 18 19 19 20 20 RS33 82K QS07 CS04 120P RS07 N 1 D RS30 3.3K RS10 33K RS13 22K DS02 CS08 4.7u CS06 4700P RS12 100K DS03 RS18 1K H-IN SM-3/10P CS07 1u CS16 180P RS19 1K CS15 N DS01 RS14 5.6K CS12 .01 CS09 .068 ML QS02 DTC144 DS05 DS04 C C QS04 V-IN SM-2/10P RS20 33K RS15 56K RS21 33K CS17 10 RS22 33K CS18 10 QS03 G SM-1/10P CS24 39P CS13 4.7 RS16 56K RS23 33K CS14 180P RS17 1.5K QS05 V2 MASK-8/8P CM04 220P QM04 RM10 6.8K B RM19 330 ZDM01 5.1V RM02 47K QM01 RM05 2.2K RM04 1K 9 MASK-3/8P 9 8 8 10 10 7 7 11 11 6 6 12 12 5 4 4 3 BLANK RM17 1.2K DM01 CM05 4700P RM14 10K CM09 220P CM01 1000P ML 5V RM03 3.9K 5V CM02 47 16V RM06 10K NC MASK-2/8P 5 13 13 14 14 ICM01 4538 3 15 2 16 16 1 1 RM20 150 .5W AFC 15 QM03 CM07 47 16V MASK-4/8P B RM16 4.7K DM02 5V 2 5V RM15 10K RM09 1K RM11 18K MASK-1/8P RM18 18K RM13 3.3K QM02 CM03 4700P ML LEFT MASK-6/8P CM08 .1u A A RIGHT MASK-5/8P CM06 .1u PAGE 9 SAMPO CO.ELECTRONIC RD2 (S-M.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number SYNC & MASK Date: Monday, November 19, 2001 Rev 0 Sheet 9 1 of 14 8 7 6 5 4 3 2 1 D D RV40 2.7K 2W U-1/5S U-3/5S P3 208V P5 12V CV1 47 16V P5 U-2/5S P5 U-4/5S RV11 1K RV38 2.7 .5W CV12 1000P RV28 820 QV08 QV11 C Y CV06 4700P RV03 560 QV04 RV15 56 RV16 3.9K CV7 560P RV13 330 RV10 2.2K RV12 470 .5W RV43 27K RV42 27K DV01 RV20 8.2K RV24 2.2K RV22 2.2K QV05 FBV01 RV30 68K DV08 TP CV15 100P 1 RV32 12K RV27 82 CV16 4700P 500V RV31 68K DV07 QV12 CV18 47 200V RV34 1.2K DV06 CV11 2.2u RV39 330 2W FBV02 CV17 100P RV33 820 RV23 10K RV06 12K PA-2/2S CV14 4700P 500V RV25 10 .5W QV10 RV21 2.2K CV08 .01 DV02 V PINS RV26 82 DV04 CV09 .1 CV10 2.2u CV19 47 200V QV09 RV17 3.9K RV19 56K RV41 33K PA-1/2S RV36 56 .5W DV05 CV13 47 16V DV03 QV06 P5 U-5/5S RV29 1.2K QV07 QV02 C CV23 10 200V RV18 39K RV14 1.5K RV35 56 VM COIL CV21 56P 500V DSD 2 CV22 10 200V RV37 2.7/.5W B B A A PLAG 10 SAMPO CO. ELECTRONIC RD2 (VM.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number VM Date: Monday, November 19, 2001 Rev 0 Sheet 10 1 of 14 8 7 6 5 4 3 2 1 1 -1/3P 2 -2/3P 3 -3/3P D D FR RGB182 15 5 RGB SW SCL 10 14 4 3 B H 8 12 2 G SDA 7 11 1 V P1 FR-12/12P 11 GND P1 FR-11/12P 10 H P1 FR-10/12P 9 RGB SW P1 FR-9/12P 8 SCL P1 FR-8/12P 7 SDA P1 FR-7/12P 6 GND P1 FR-6/12P 5 B P1 FR-5/12P 4 GND P1 FR-4/12P 3 G P1 FR-3/12P 2 GND P1 FR-2/12P 1 R P1 FR-1/12P P2 B-8/8P P2 B-7/8P P2 B-5/8P P2 B-6/8P P2 B-1/8P V 9 13 12 R 6 QSOCD1549-115 C C B-4/8P B-3/8P P2 R068 820 STBY 5V P2 R018 820 R/C2 2 1 R/C 3 RECEIVER R035 820 1 2 3 LD001 VSPHB5-133 POWER LD002 VSPHB5-134 SUSPEND LD003 VSPHB5-132 STBY VSILTM9236E R/C PIN1 B-2/8P R052 1KF MR R055 1KF R054 1KF MR R053 MR 820F P2 SW002 SW-1199 MENU- SW003 SW-1199 SW004 SW-1199 VOL+ VOL- MR R046 MR 1.2KF SW005 SW-1199 MENU+ R048 1.5KF MR SW006 SW-1199 SW007 SW-1199 I/P SEL RO49 N DEGAUSS SW001 SW-1199 POWER B B GND SV AV2 V 1 S S SV-1/10P 2 V V SV-2/10P GND SV-3/10P R SV-4/10P GND SV-5/10P L SV-6/10P GND SV-7/10P 3 R 4 L R 5 6 L 7 8 Y Y SV-8/10P 9 10 C C SV-9/10P GND SV-10/10P S C Y S A A PAGE 11 SAMPO CO. ELECTRONIC RD2 (LED.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number LED Date: Monday, November 19, 2001 Rev 0 Sheet 11 1 of 14 8 7 6 5 4 3 2 1 C8A2 10 R890 1.5K IC804 7805FA VI 9 8 9 10 10 7 11 11 6 12 12 5 13 13 15 14 14 4 3 R895 1K 2 C8E3 10 R866 1K D R888 1K C8P2 220 16V C8E2 10 R894 1K C8E1 10 R893 1K C849 10 C846 10 8 Q813 7 C848 10 6 Q814 5 42 9V 4 3 VO 3 FR1-1/9P R867 1K PI-5/10P 2 TM1-3/8P R865 1K FR1-3/9P C845 10 IC813 M52055 2 1 C8P1 100u 16V Q815 15 16 IC805 78L09FA GND 13V DB-1/9P C847 10 43 R887 1K 16 C8P4 220 16V D R8P1 5.6 1W FR1-5/9P C844 10 5V 2 C8P3 100u 16V 3 VO R892 1.5K 1 VI R891 1.5K 1 1 GND R8P2 33 1W 41 R889 1K PI-3/10P PI-1/10P R8E1 68K R8E3 1.8K 9V R8E4 1.2K R886 1K C874 .1 R Q818 R885 1K C873 .1 9V TA-5/14P OSD G TA-6/14P OSD B TA-7/14P R8H5 0 G 9V OSD R R8H4 0 B R896 8.2K Q816 C875 .01 R C872 .1 U B R898 3.3K G C877 1u 2 C884 2.2u BLK J1 J2 J7 R883 10K RY05 22K C871 2.2 9 C870 2.2 31 32 33 30 30 31 32 33 34 C IC812 Q831 9 8 10 7 11 6 12 5 8 RY04 10K C888 2200P 11 5V 12 Cr 7 6 5 5V C889 220 16V IC801 13 TA1276AN ZD808 R874 330 C C8A1 .01 Y 5V 5V C855 15P C859 330 16V B C854 12P F 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 F C856 2200P ML X802 3.58M F RY08 47K 28 C890 180P 14 15 16 C865 .01 R875 10K 13 4 14 3 15 2 4 R8E6 5.6K 3 RY07 100K 2 28 27 27 26 26 25 24 25 23 24 22 23 22 21 21 20 20 19 19 17 16 18 18 R877 390 C861 2.2 1 16 R878 2.2K 74HC4538 FBP R880 100 1 C891 180P 5V SCL R879 100 9V C858 .01 C862 100 16V R872 10K X801 4.43M 17 15 C860 .1 63V 16 15 14 13 13 12 12 11 11 10 8 9 10 9 8 7 7 6 5 6 C851 10 FSC 5 4 4 3 2 3 1 2 1 R871 330 14 C843 1u V-SYNC R864 75 X803 503KHZ C864 .01 R873 30K C857 .22 C867 100 16V C865 .022 ML R876 3.3K PI-7/10P R8A6 47K 8 8 9 9 10 10 11 11 12 13 13 12 6 5 4 3 7 7 R8A7 47K D806 Q832 DTC144 6 R8A5 4.7K FR1-7/9P RY10 2.2K 5 C868 560P 2 D805 R8A4 68K R8A9 10K RY11 2.2K IC814 74LS125 4 R8A1 10K PI-9/10P 3 R8A8 10K Q810 R8A3 4.7K Q809 D803 V1 TM15/8P RY13 2.2K FR1-9/9P RY12 2.2K Q811 DTC144 C8A7 470P RY15 1K Q812 DTC144 C869 4.7 SD TA-4/14P 16 17 18 R8E9 12K Q820 16 17 V-SYNC 18 19 C8M6 1 19 20 C8M5 1 20 21 22 21 23 R8F7 1K Q821 R8F8 1K C8M7 1u C8M8 0.47u 23 24 24 25 25 26 26 27 27 28 C8M9 0.47u 22 C8N0 0.1u C8N1 0.1u 28 29 29 30 30 C8N2 0.1u TA-1/14P R8F4 2.2K 2 D802 TVD V0 R8A2 5.6K 1 R8A0 22K C863 22P C887 47 14 9V F V2' 9V 1 D804 14 16 16 15 15 14 13 14 13 12 12 11 10 11 10 9 9 9V R870 18K B R859 8.2K C866 2.2 RY14 9V D801 D DB-5/9P H-SYNC 5.6K 9V R868 100K DB-3/9P SDA MODE IC802 M52055P C850 .01 TA-9/14P TA-3/14P R8H1 1K 34 35 37 39 38 37 B 38 40 G 39 41 R 40 41 42 42 44 43 43 45 44 46 OSD BLK J8 10 45 48 49 47 46 V 47 U 49 Y 50 51 51 52 52 54 53 53 55 54 55 56 ZD807 56 5V C842 1u R882 1K C878 100 16V C879 2.2u C881 .1 48 C883 .1 63V Cb R863 75 J6 R8H2 10K ZD806 C885 2.2u J5 J4 J3 35 R862 75 R8H3 0 R884 1K RY06 6.8K BLK 36 C C880 1 50 Y C882 .1 C876 100 R897 100 36 C841 10u 15K R8E5 68K 29 J VM 29 1 IC816 A A C8J4 0.1u C8J8 0.1u C8M1 10u C8J9 0.1u 15 DB-7/9P V2' V2' SAMPO CO. ELECTRONIC RD2 (AV1.SCH) C8M4 0.47u C8M2 0.47u SME-32DL5(P) C8M3 47u 7 DB-8/9P V1 PAGE 12 R8F6 1K R8F5 10K V0 15 14 14 13 13 12 12 11 11 10 10 9 9 8 7 C8J7 0.1u 8 7 6 0.1u C8J5 0.1u C8M0 47u 8 C8J6 6 4 5 5 4 2 3 3 2 1 1 TA8772AN 6 5 4 3 2 Size C Document Number AV + YPBPR + YCBCR Date: Monday, November 19, 2001 Rev 0n Sheet 12 1 of 14 8 7 6 5 4 3 2 1 5V 5V V1 V1 V1 R848 560 R841 4.7K Q804 C8K0 1000P 10u C824 39P L804 10u R816 100K C R843 1.8K C820 39P R844 1K C8C0 .01 C8C4 .01 C810 10u X0 A 9 10 X3 1 1 15 14 R8J6 4.7K R R8J5 100K S3 R8J8 4.7K C L R8J7 100K SF-3/3P DB-9/9P L SF-1/3P 8 8 7 V2' V2 B 9V R861 2.2K D809 R856 6.8K CONTROL VS-1/11P R8H9 100K Y C 5 6 8 9 7 9 10 10 11 11 12 12 13 13 14 14 15 16 C8J2 1000P R834 4.7K 15 R836 4.7K 8 IC810 NJM2234D C834 10u 4 3 2 1 8 7 6 6 5 5 4 4 3 3 2 C8J3 1000P 2 IC809 4052 C825 10u R833 100K ZD802 R860 2.2K V1 C831 10u 9V 16 L AV2 VIDEO TA-2/14P D811 Q806 DTC144 B 7 6 5 6 5 4 Y1 4 3 Y3 3 2 2 1 1 R C807 10u R8J4 33K C8A0 2.2u 9 10 11 12 12 11 11 10 9 Y C826 10u R835 100K C806 10u Y2 Q819 DTC144 100K R811 4.7K R808 75 0 R 11 X 12 13 X1 13 14 14 16 15 15 X2 R8H8 YPBPR C8J1 1000P 1 C8P8 10u 9V R807 100 C8K9 1000P R810 100K 0 S3 R830 100K C808 10u R813 4.7K Q805 DTC144 R857 5.6K C805 10 R809 100 VS-3/11P Y0 R832 100K C815 10 V0 AV2L 10 9 8 8 7 7 6 6 5 4 V0 5 4 3 3 2 V1 C801 10u V0 R812 100K 0 0 Q822 DTC144 IC808 4052 9V V1 AV2 R 0 1 V2' R8H7 100K R831 100K 1 R8T1 2.2K 0 1 D810 1 TA1-11/14P 2 1 1 TUNER VIDEO 1 RGB1 C832 10u TUNER L B RGB2 D 14 13 13 12 12 11 10 11 10 9V R858 5.6K R828 100K IC806 M52472 C817 10u 0 V3 R829 100K 12 13 13 14 14 15 15 16 16 17 17 18 18 19 19 20 20 21 C8K7 C812 10u 1 TUNER C816 10 1000P TA1-14/14P 1 CCD VIDEO 16 VIDEO OUT 1 R826 47K 9V 22 R821 100K 0 Y Cb Cr C8P5 1000P CCD VIDEO C813 10u R822 4.7K L ZD803 C8K6 1000P 1 C8P7 1000P R8C1 220 R827 100K R823 100K 1 TM-4/6 R825 47K R820 100 C814 10u 21 R R819 150 C811 470 16V R824 4.7K 0 R8C3 10K 9V 9V 10 Q801 22 R818 75 0 AV2 15 16 16 17 18 17 18 19 19 20 20 9 8 9 C8C6 100 16V 7 100u 16v 0 1 C8P6 10u SCL V 1 0 FSC C8C7 100 16V R8C0 220 C818 47 16V R8H6 9V VS-7/11P 8 7 7 C8C3 22 16V R802 100 TUNER R C8N4 VS-5/11P C8A5 47u 16V R8C4 10K SDA TA1-12/14P DB-8/9P C8A4 100P R8C2 10K SCL SCL 0 FSC C8C5 .01 SDA SDA 21 22 23 6 5 L805 100u 6 5 4 4 3 3 2 2 1 C823 1u 5V C8K5 1000P 0 1 IC807 TC9090AN 1 C809 10u R817 4.7K R TV AV1 Q803 R842 560 C8K3 1000P C8K4 1000P V3 10u R815 4.7K R814 100K R8C7 820 C838 .01 23 24 24 C822 33P 25 28 R845 820 C840 .01 21 C8C2 22 16V R847 100 R846 220 R805 100K L V2 C8C9 120P C836 180P 9V YCBCR C837 .01 DB-7/10P V1 C8C8 .01 10u C8K2 1000P C804 L801 100u R8C5 10K R8C6 10K C839 .01 C821 120P C803 R803 100K R806 4.7K C819 220 16V 25 R804 4.7K R Q802 ZD801 L806 100u C835 .01 R8C8 12K R8C9 7.5K 26 R801 75 L C8C1 .01 C8K1 1000P 26 C802 10u V L802 100u R850 100 C827 10u R837 100K AV1 5V C8A3 100 16V 22 R838 4.7K 27 R840 100K 27 D L803 15u C828 28 PSF TO Main Board R849 220 V0 V2' C833 10u R869 22K R8F2 22K R8F3 15K D808 A A F Y3 R8J0 82 C8N7 10u ZD812 J R8J1 47K S3 V0 D V0 D807 C3 R8J2 82 C8N8 0.01 ZD813 R855 22K Q807 DTC144 PAGE 13 R8J3 1K SAMPO CO.ELECTRONIC RD2 (AV2.SCH) SME-32DL5(P) 8 7 6 5 4 3 2 Size C Document Number AV + YCBCR + YPBPR Date: Monday, November 19, 2001 Rev 0n Sheet 13 1 of 14 A B C D E 4 C5 C1 330P 47u16V + D1 1N4148 C2 1u/50V 3 C3 18P R3 RS 4.7K N R8 N CN1 C4 18P DA2/P5.2 VSYNC 42 2 DA1/P5.1 HSYNC 41 3 DA0/P5.0 DA3/P5.3 40 4 V33CAP/NC DA4/P5.4 39 5 DM/NC DA5/P5.5 38 6 DP/NC DA8/HALFH 37 7 RST DA9/HALFV 36 8 VDD HBLANK/P4.1 35 9 VSS VBLANK/P4.0 34 R4 10 X2 DA7/HCLAMP 33 4.7K 11 X1 DA6/P5.6 32 12 ISDA/P3.4/T0 P2.6/DA12 31 ISCL/P3.5/T1 P2.5/DA11 30 STOUT/P4.2 P2.4/DA10 29 HSCL/P3.0/Rxd 28 +5V 5 4 3 2 1 N R9 IC01 1 X1 11.0592MHZ R11 R1 100 SDA R2 100 13 SCL 14 15 16 C7 N 1 V 4 G N R10 D- 2 D+ N 3 R7 N 3 IC02 HIN232CB RS232 C8 1u/16V(NP) 1 P1.0 HSDA/P3.1/Txd 27 P1.1 P2.0/AD0 26 18 P3.2/INTO P2.1/AD1 25 19 P1.2 P1.7 24 17 2 P2.2/AD2 C6 N R5 R6 C9 3 1u/16V(NP) 4 33 33 5 16 20 P1.3 P1.6 23 21 P1.4 P1.5 22 C10 47u/16V + + 4 C11 0.1u C12 0.1u C13 0.1u P1 DB9-MALE TXD C1+ T1-IN 11 C1- R1-OUT 12 C2+ R1-IN 13 T1-OUT 14 T2-OUT 7 TP16 C2VCC RXD R12 33 R13 33 2 V+ R2-IN 8 TP17 6 V- R2-OUT 9 TP18 10 TP19 15 GND T2-IN 5 9 DTR 4 CTS 8 3 RTS 7 2 DSR 6 1 SD RD C14 180p C15 180p 10 11 2 MTV212MS64U 1 1 PAGE 14 SAMPO CO. ELECTRONIC RD2 (RS232.SCH) SME-32DL5(P) A B C D Size B Document Number RS232 Date: Monday, November 19, 2001 Rev 0 Sheet E 14 of 14 SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 1. MAIN BOARD * - represent the critical component **** MAIN PWB BR701 C001 C002,044 C011,012 C013 C015,022~026 C020,033 C021 C028,029,035 C030 C031,068 C034 C037,043,050 C042 C045,046 C047 C049 C051,052,053 C060~064 C066,067,0C1 C073,075,076 C080,099 C086 C104~107 C112,114 C121,121L,122 C131 C190A~192A C501 C502 C503 C504 C505 C507 C510,511,530 C512 C601 C602 C603,670,6D0 C604 C605 C606 C607 C612,614 C613,617,686 C615 C620,621,667 C622,651,653 81 54 21 20 84 20 79 44 68 79 77 69 28 79 52 22 43 53 88 79 79 79 20 26 53 53 43 17 53 79 18 53 81 77 29 20 87 26 27 77 67 09 49 30 17 50 52 77 20 QPWB51060-1G-BVSIGBU6J------VCEACU1CG477M-P VCKBDU1HY103K-P VCDCDU1HH120J-P VCEACU1CG107M-P VCSFDU1HY104Z-P VCKBDU1HY102K-P VCKBDU1HY101K-P VCSFDU1HY104Z-P VCEACU1HG105M-P VCKBDU1HY471K-P VCEACU1AG108M-P VCSFDU1HY104Z-P VCEACU1AG107M-P VCDCDU1HH330J-P VCMECU1JG473J-P VCEACU1AG477M-P VCKBDU1HY331K-P VCSFDU1HY104Z-P VCSFDU1HY104Z-P VCSFDU1HY104Z-P VCKBDU1HY103K-P VCEACU1HG226M-P VCEACU1HG106M-P VCEACU1HG106M-P VCEACU1VG476M-P VCEACU1CG226M-P VCEACU1HG106M-P VCSFDU1HY104Z-P VCEACU1VG107M-P VCEACU1HG106M-P VCPELF1HG224J-VCEACU1HG105M-P VCEACU1HG107M-P VCKBDU1HY103K-P VCSBDU1HY223K-P VCEACU1HG226M-P VCKBDU2HY221K-P VCEACU1HG105M-P VCEACU1JG107M-P VCMPHF2AG824J-RC-MP912J-13C-VCKBDU2HY102K-P VCKBDF2HY682K-VCDCDU2HH220J-P VCEACU1AG107M-P VCEACU1EG107M-P VCKBDU1HY103K-P MAIN BOARD IC GBU6J 470uF 16V ±20% .01uF 50V ±10% 12PF 50V ±5% 100uF 16V ±20% .1uF 50V +80%-20% 1000PF 50V ±10% 100PF 50V ±10% .1uF 50V +80%-20% 1uF 50V ±20% 470PF 50V ±10% 1000uF 100V ±20% .1uF 50V +80%-20% 100uF 10V ±20% 33PF 50V ± 5% .047uF 63V ± 5% 470uF 10V ±20% 330PF 50V ±10% .1uF 50V +80%-20% .1uF 50V +80%-20% .1uF 50V +80%-20% .01uF 50V ±10% 22uF 50V ±20% 10uF 50V ±20% 10uF 50V ±20% 47uF 35V ±20% 22uF 16V ±20% 10uF 50V ±20% .1uF 50V +80%-20% 100uF 35V ±20% 10uF 50V ±20% .22uF 50V ±5% 1uF 50V ±20% 100uF 50V ±20% .01uF 50V ±10% .022uF 50V ±20% 22uF 50V ±20% 220PF 500V ±10% 1uF 50V ±20% 100uF 63V ±20% .82uF 100V ±5% 9100PF 1.6KV ±5% 1000PF 500V ±10% 6800PF 500V ±10% 22PF 500V ±5% 100uF 10V ±20% 100uF 25V ±20% .01uF 50V ±10% 9-1 Aluminum Elect. High Diel. Ceramic Temp. Comp. Ceramic Aluminum Elect. Semiconductor Ceramic High Diel. Ceramic High Diel. Ceramic Semiconductor Ceramic Aluminum Elect. High Diel. Ceramic Aluminum Elect. Semiconductor Ceramic Aluminum Elect. Temp. Comp. Ceramic Metal Ploy. Film Aluminum Elect. High Diel. Ceramic Semiconductor Ceramic Semiconductor Ceramic Semiconductor Ceramic High Diel. Ceramic Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Semiconductor Ceramic Aluminum Elect. Aluminum Elect. Polypropylene Film Aluminum Elect. Aluminum Elect. High Diel. Ceramic Semiconductor Ceramic Aluminum Elect. High Diel. Ceramic Aluminum Elect. Aluminum Elect. Metal Ploy. Film Metal Ploy. Film High Diel. Ceramic High Diel. Ceramic Temp. Comp. Ceramic Aluminum Elect. Aluminum Elect. High Diel. Ceramic SME-32DL5(P) ELECTRONIC PARTS LIST C623 C624 **** C625 C631 C634,638,639 C635 C637,655 C640 C643 C644 C645 C646,680,6T1 C647,696 C648 C649 C650 C654,662 C660,699 C661,664,666 C663 C665 C668 C669 C671 C672 C674,6D3 C675,6E4 C682,684 C691 C692 C693 C694,6C3 C697 C6A0,6A3 C6A1 * C6A4 C6A6 C6A9,6B1 C6C1 71 64 32 41 50 84 21 60 15 68 53 20 18 08 54 42 10 44 79 45 21 30 15 22 18 79 20 17 77 88 80 68 11 21 03 87 64 20 03 C6C2,6C9,6P1 53 C6C6 26 C6D2 28 C6D4 88 C6D6 41 82 * C6D7 26 * C6D9 C6E0 14 C6E1,6E5,6E6 68 C6E2 86 C6E3 39 C6E8 82 VCPPHF3CG272J-VCKBDU1HY332K-P VCPPLU2AY102G-P VCKBDU1HY221K-P VCEACU1HG225M-P VCPPLU2AY681G-VCEACU1CG477M-P VCPELU1HG104J-P VCPELU1HG333J-P VCKBDU1HY101K-P VCEACU1HG106M-P VCEACU1CG107M-P VCMECU1JG104J-P RC-MP103J-13C-VCPPHF2JG822J-VCPPHF2GG272J-VCMECU2AG222J-P VCKBDU1HY102K-P VCSFDU1HY104Z-P VCKBDU1HY472K-P VCKBDU1HY392K-P VCDCDU1HH680J-P VCPPHF2GG224J-VCEACF2EG107M-VCPPHF2DG123J-VCSFDU1HY104Z-P VCKBDU1HY271K-P VCKBDF2HY682K-VCPELU1HG123J-VCMPHF2AG103G-VCMECU1JG224J-P VCMECU2AG822J-P VCMECU1JG124J-P VCEACU1CG477M-P VCDCDU1HH470J-P VCPELU1HG563J-P VCEACF1CG336M-P VCKBDU1HY103K-P VCEACU1JG476M-P VCEACU1HG106M-P VCKBEF3DY103Z-VCPPHF3CG392J-VCEACU2EG476M-P VCMPHF2EG225J-VCEACU1CG227M-P VCEACU1HG226M-P VCENCU2DG475M-VCKBDU1HY101K-P VCPPHF2GG333J-VCKBDU3AY102K-P VCKBDU2HY681K-P 3300PF 3300PF 1000PF 220PF 2.2uF 2700PF 470uF .1uF .033uF 100PF 10uF 100uF .1uF .01uF 8200PF 2700PF 2200PF 1000PF .1uF 4700PF 3900PF 68PF .22uF 100uF .012uF .1uF 270PF 6800PF .012uF .01uF .22uF 8200PF .12uF 470uF 47PF .056uF 33uF .01uF 47uF 10uF .01uF 3900PF 47uF 2.2uF 220uF 22uF 4.7uF 100PF .033uF 1000PF 680PF VER1.0 1.6KV ±5% Polypropylene Film 50V ±10% High Diel. Ceramic 100V ±2% Polypropylene Film 50V ±10% High Diel. Ceramic 50V ±20% Aluminum Elect. 200V ±2% Polypropylene Film 16V ±20% Aluminum Elect. 50V ±5% Polypropylene Film 50V ±5% Polypropylene Film 50V ±10% High Diel. Ceramic 50V ±20% Aluminum Elect. 16V ±20% Aluminum Elect. 63V ±5% Metal Ploy. Film 1.6KV ±5% Metal Ploy. Film 630V ±5% Polypropylene Film 400V ±5% Polypropylene Film 100V ±5% Metal Ploy. Film 50V ±10% High Diel. Ceramic 50V +80%-20% Semiconductor Ceramic 50V ±10% High Diel. Ceramic 50V ±10% High Diel. Ceramic 50V ±5% Temp. Comp. Ceramic 400V ±5% Polypropylene Film 250V ±20% Aluminum Elect. 200V ±5% Polypropylene Film 50V +80%-20% Semiconductor Ceramic 50V ±10% High Diel. Ceramic 500V ±10% High Diel. Ceramic 50V ±5% Polypropylene Film 100V ±2% Metal Ploy. Film 63V ±5% Metal Ploy. Film 100V ±5% Metal Ploy. Film 63V ±5% Metal Ploy. Film 16V ±20% Aluminum Elect. 50V ±5% Temp. Comp. Ceramic 50V ±5% Polypropylene Film 16V ±20% Aluminum Elect. 50V ±10% High Diel. Ceramic 63V ±20% Aluminum Elect. 50V ±20% Aluminum Elect. 2KV +80%-20% High Diel. Ceramic 1.6KV ±5% Polypropylene Film 250V ±20% Aluminum Elect. 250V ±5% Metal Ploy. Film 16V ±20% Aluminum Elect. 50V ±20% Aluminum Elect. 200V ±20% Aluminum Elect. 50V ±10% High Diel. Ceramic 400V ±5% Polypropylene Film 1000V ±10% High Diel. Ceramic 500V ±10% High Diel. Ceramic 9-2 SME-32DL5(P) ELECTRONIC PARTS LIST C6I1 C6I2 C6I3,6T2 C6I4,6I6 C6I5 C6I7 **** C701,704 **** C702,703 C705 **** C706,707 **** C709 C711 C712 * C713 C714,7P1 C715,719 C716 C717 C726 C727,735 C731 **** C732,733 C736,718 C737 C741~745,796 C755 C756 C757 C758,766 C760 C764 C765 C767 C7A2 CR01 D001,005,009 D035,038 D104~113 D503 D601 D602 D603 D604,607 D605,606 D609,630 D610,611 D614,616~618 D615 D620 D621,622,631 D640~644 70 47 82 73 78 70 65 33 36 61 16 84 50 12 43 53 45 35 84 78 79 61 44 10 20 52 04 88 53 17 21 52 26 60 20 89 89 89 89 34 01 24 89 09 73 89 89 74 67 89 89 VCEHCF1HG475M-VCKBDU1HY562K-P VCEACU1CG227M-P VCEACU1HG336M-P VCEACU1HG475M-P VCMECU1JG683J-P VCPEEF7EY474MX1 VCKEDF7GY222MX3 VCKEDF7GY103MX3 VCKEDF7GY472MX3 VCEALS2GY337M-VCEACU2EG225M-P VCEACU1HG225M-P VCEACU1HG104M-P VCEACU1VG476M-P VCEACU1HG106M-P VCKBDU1HY472K-P VCPELU1HG152J-P VCPELU1HG103J-P VCEACU1HG475M-P VCSFDU1HY104Z-P VCKEDF7GY103MX3 VCKBDU1HY102K-P VCMECU2AG222J-P VCEACU1CG107M-P VCDCDF3AH101K-VCEACF2EH107M-VCEACU2EG476M-P VCEACF1HG108M-VCEACF1CG228M-P VCEACU1CG477M-P VCEACU1AG107M-P VCEACU1HG226M-P VCEACU2EG226M-P VCENCU1CG476M-VSD1N4148-----U VSD1N4148-----U VSD1N4148-----U VSD1N4148-----U VSDFR104------VSDMUR115-----VSDFMQG5FMS---VSD1N4148-----U VSDRGP30G175--VSDSUF30J-----VSD1N4148-----U VSD1N4148-----U VSD1N4002-----U VSDRGP10G-----U VSD1N4148-----U VSD1N4148-----U 4.7uF 5600PF 220uF 33uF 4.7uF .068uF .47uF 2200PF .01uF 4700PF 330uF 2.2uF 2.2uF .1uF 47uF 10uF 4700PF 1500PF .01uF 4.7uF .1uF 10NF 1000PF 2200PF 100uF 100PF 100uF 47uF 100uF 2200uF 470uF 100uF 22uF 22uF 47uF Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode 50V ±20% 50V ±10% 16V ±20% 50V ±20% 50V ±20% 63V ±5% AC250V ±20% AC400V ±20% AC400V ±20% AC400V ±20% 400V ±20% 250V ±20% 50V ±20% 50V ±20% 35V ±20% 50V ±20% 50V ±10% 50V ±5% 50V ±5% 50V ±20% 50V +80%-20% AC400V ±20% 50V ±10% 100V ±5% 16V ±20% 1000V ±10% 250V ±20% 250V ±20% 50V ±20% 16V ±20% 16V ±20% 10V ±20% 50V ±20% 250V ±20% 16V ±20% 1N4148 1N4148 1N4148 1N4148 FR104 MUR115 FMQG5FMS 1N4148 RGP30G SUF30J 1N4148 1N4148 1N4002 RGP10G 1N4148 1N4148 9-3 VER1.0 Aluminum Elect. High Diel. Ceramic Aluminum Elect. Aluminum Elect. Aluminum Elect. Metal Ploy. Film Polypropylene Film High Diel. Ceramic High Diel. Ceramic High Diel. Ceramic Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. High Diel. Ceramic Polypropylene Film Polypropylene Film Aluminum Elect. Semiconductor Ceramic High Diel. Ceramic High Diel. Ceramic Metal Ploy. Film Aluminum Elect. Temp. Comp. Ceramic Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. Aluminum Elect. SME-32DL5(P) ELECTRONIC PARTS LIST **** **** **** D661,663,694 D664 D6C1,6C2 D6C5 D6C6,6I1,6K1 D6C7 D701,713,714 D711,754 D712 D731,741 D753 D755,756 D757 D759 D793,7P1,7P2 D7A1 F701 FB101~103 FB601 FB602~604 FB701,702 FB703 FB711,711A FB751 IC001 IC002 IC003 IC004 IC006 IC101 IC102 IC106 IC501 IC631 IC632 IC661 IC691 IC6C1 IC711 IC712,713 IC731 IC791 IC792 IC793 J266 L001 L601 L602 L603 L604 L605 L661 L6C1 89 37 03 09 89 32 89 16 50 89 85 45 25 38 89 03 03 69 15 69 80 69 15 15 59 49 76 35 81 71 69 19 81 11 15 18 86 68 13 15 89 54 84 04 73 85 48 30 33 67 30 49 88 VSD1N4148-----U VSDSF16-------U VSDRGP02-16E--U VSDHER305-----VSD1N4148-----U VSDRGP10D-----U VSD1N4148-----U VSDBYV26DGP---U VSDFR103------U VSD1N4148-----U VSDBY329X1200-VSDHER303-----VSDSR2100-----U VSDFR203------U VSD1N4148-----U VSD1N4001-----U QFS-D312S-12Y-RCORA1037-1---U RCORA1021-1---U RCORA1037-1---U RCORA1004-1---RCORA1037-1---U RCORA1021-1---U RCORA1021-1---U VSIP87C380----VSIM24C08BN6--VSIMC141541P--VSIM62393P----VSIS-80740AH--VSI74LS125AN--VSIM52055P----VSIAT24C21----VSITDA8351----VSI74HC221----VSILM358N-----VSIUC3843-----VSITDA4854----VSINJM2904D---VSIKA3842A----VSIPC817C-----VSITL431CZ----P VSILM2940CT12-VSINJM7805FA--VSINJM7809FA--VRCPTV6--182J-U VL-DH120K0000-U RCILL1074-1---RCILL1075-1---RCHOM1077-1320RCHO-1132-1---VL-DH680K0000-U RCHO-1139-1502B RCHO-1141-1502- Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Fuse Core Core Core Core Core Core Core IC IC IC IC IC IC IC IC IC IC IC IC IC IC IC IC Transistor IC IC IC 1.8K ohm Peaking coil Coil Coil Choke Choke Peaking coil Choke Choke 9-4 1N4148 SF16 RGP02-16E HER305 1N4148 RGP10D 1N4148 BYV26DGP FR103 1N4148 BY329X1200 HER303 SR2100 FR203 1N4148 1N4001 3.1A/250V P87C380 M24C08BN6 MC141541P M62393P 80740H LS125AN M52055P AT24C21 TDA8351 74HC221 LM358N UC3843 TDA4854 NJM2904D KA3842A PC817C TL431CZ LM2940CT12 NJM7805 NJM7809FA 1/6W 5% Carbon Film 12uH 68uH 5Mh 5Mh VER1.0 SME-32DL5(P) ELECTRONIC PARTS LIST L6I1 L751,752,757 L762 L831 Q001~003 Q010,012,034 Q031,035 Q101 Q102~104 Q120~122 Q501,502 Q503 Q601 Q602,631,635 Q603 Q604 Q605,611,624 Q606,608 Q607,609 Q612 Q613 Q615,622,623 Q620,629 Q621, 634 Q625,630 Q632 Q661,664,691 Q663,6D3 Q665,6D4 Q692 Q693 **** 36 47 47 28 01 82 01 82 57 57 01 82 06 01 63 38 67 50 66 22 86 87 50 82 66 36 01 87 50 63 75 Q694~696,6T1 82 Q6C4 46 Q6C7 27 Q6C8 78 Q6C9 48 Q6D1 67 Q6D2,6D9 01 Q6I1 70 Q6I2 43 Q6I3 23 Q6I4,6I5,6P1 01 Q701,712 01 Q711 82 Q713 86 Q731,732 01 Q7A1 20 Q7A2 87 Q7A3 75 R001,004 31 R002 05 R003,013,022 10 R005 07 RCHO-1129-1371RCHO-1103-1111RCHO-1103-1111VL-DH101K0000-U VST2SC1815Y---P VSIDTC144ES---P VST2SC1815Y---P VSIDTC144ES---P VST2SC1906----P VST2SC1906----P VST2SC1815Y---P VSIDTC144ES---P VST2SC3610---VST2SC1815Y---P VST2SA1020Y---P VST2SC5422----VST2SC1318R---P VSTIRF740-----VSTKSP42------P VSTBD139------VSTBD140------VST2SA1015Y---P VSTIRF740-----VSIDTC144ES---P VSTKSP42------P VSTMPS3646----P VST2SC1815Y---P VST2SA1015Y---P VSTIRF740-----VST2SA950Y----P VST2SC2120Y---P VSIDTC144ES---P VST2SC4152----VST2SC1213C---P VST2SA673C----P VST2SK1358----VST2SC1318R---P VST2SC1815Y---P VST2SB861WC---VST2SB716ADTZ-P VST2SD667AC---P VST2SC1815Y---P VST2SC1815Y---P VSIDTC144ES---P VSTSTW11NB80--VST2SC1815Y---P VST2SC3467E---P VST2SC2688----VST2SA1480E---VRCPTV6--221J-U RNWRA2019-1332 VRCPTV6--103J-U VRCPTV6--222J-U Coil Choke Choke Peaking Coil Transistor IC Transistor IC Transistor Transistor Transistor IC Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor IC Transistor Transistor Transistor Transistor Transistor Transistor Transistor IC Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor IC Transistor Transistor Transistor Transistor Transistor 220 ohm 3.3K ohm 10K ohm 2.2K ohm 9-5 VER1.0 Pincushion coil 100uH 2SC1815Y DTC144ES 2SC1815Y DTC144ES 2SC1906 2SC1906 2SC1815Y DTC144ES 2SC3610---2SC1815Y 2SA1020Y 2SC5422 2SC1318R IRF740 KSP42 BD139 BD140 2SA1015Y IRF740 DTC144ES KSP42 MPS3646 2SC1815Y 2SA1015Y IRF740 2SC950Y 2SC2120Y DTC144ES 2SC4152 2SC1213C 2SA673C 2SK1358 2SC1318R 2SC1815Y 2SB861WC 2SB716ADTZ 2SD667AC 2SC1815Y 2SC1815Y DTC144ES STW11NB80 2SC1815Y 2SC3467E 2SC2688 2SA1480E 1/6W 5% Carbon Film 1/6W 1/6W 5% Carbon Film 5% Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST R007 R008,019,6J4 R010 R011,012,071 R014,028 R015,045 R016 R018,035,053 R020,081,097 R024,041,043 R0254,005A R026 R027 R028,057,061 R033,038 R034 R036,037,039 R040,042,044 R046 R048 R050 R051 R052,054,055 R018,068 R056,060,084 R064 R066,091 R067,075 R069,073,074 R070,098,0C4 R078 R079 R080,0C7,0E1 R082,083 R085~087,0C1 R088,089,092 R090 R094,099 R095 R0A1 R0A2 R0A3,0A4 R0A7,0A8,0B1 R0A9 R0B4 R0C2,0C3 R0C6,0C9 R0E2,0E3 R101 R102 R103,104,105 R106 R107 26 73 61 78 34 59 54 74 11 10 54 13 35 34 58 11 07 58 55 84 54 34 78 89 10 10 62 76 35 54 76 14 34 58 07 10 50 10 37 02 30 58 10 75 11 58 10 10 87 64 86 72 62 VRCPTV6--153J-U VRCPTV6--182J-U VRCPTV6--561J-U VRCPTV6--331J-U VRCPTV6--102J-U VRCPTV6--471J-U VRCPTV6--332J-U VRMPTV6-8200F-U VRCPTV6--392J-U VRCPTV6--103J-U VRCPTV6--332J-U VRCPTV6--563J-U VRCPTV6--472J-U VRCPTV6--102J-U VRCPTV6--101J-U VRCPTV6--473J-U VRCPTV6--222J-U VRCPTV6--101J-U VRMPTV6-1201F-U VRMPTV6-1501F-U VRMPTV6-1002F-U VRCPTV6--102J-U VRMPTV6-1001F-U VRCPTV6—-821J-U VRCPTV6--103J-U VRCPTV6--750J-U VRCPTV6--682J-U VRCPTV6--393J-U VRCPTV6--472J-U VRCPTV6--332J-U VRCPTV6--474J-U VRCPTV6--202J-U VRCPTV6--102J-U VRCPTV6--101J-U VRCPTV6--222J-U VRCPTV6--103J-U VRCPTV6--152J-U VRCPTV6--103J-U VRCPTV6--562J-U VRCPTV6--154J-U VRCPTV6--333J-U VRCPTV6--101J-U VRCPTV6--103J-U VRCPTV6--104J-U VRCPTV6--392J-U VRCPTV6--101J-U VRCPTV6--103J-U VRCPTV6--103J-U VRCPTV4--471J-U VRCPTV2--181J-U VRCPTV6--681J-U VRCPTV6--223J-U VRCPTV6--682J-U 15K 1.8K 560 330 1K 470 3.3K 82 3.9K 10K 3.3K 56K 4.7K 1K 100 47K 2.2K 100 1.2K 1.5K 10K 1K 1K 820 10K 75 6.8K 39K 4.7K 3.3K 470K 2K 1K 100 2.2K 10K 1.5K 10K 5.6K 150K 33K 100 10K 100K 3.9K 100 10K 10K 470 180 680 22K 6.8K ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm 9-6 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/4W 1/2W 1/6W 1/6W 1/6W VER1.0 5% 5% 5% 5% 5% 5% 5% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1% 1% 1% 5% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Metal Film Metal Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST **** R108,111 R109,110 R112,114,115 R116 R120,122,123 R131,133 R134,199 R149 R190~192 R190A~192A R190B~192B R501 R502 R503 R505 R506 R507 R508 R515 R516,519 R517,518 R520 R521 R601,698 R602,619,632 R603 R604,605,613 R606 R607 R608 R609 R610 R610A R612 R614,6E8 R615,617,6F7 R616,618 R620,6A4 R621 R622 R623,633,669 R625,637,6H9 R626,655 R627~630 R631,641 R635,638 R634,668,6H1 R636 R639,6F4 R639A R639B R642,643 R645,6I7 07 35 10 51 27 35 58 27 27 74 38 65 54 57 12 38 48 13 10 07 72 62 17 86 37 51 38 29 72 30 43 14 54 61 75 35 58 62 31 72 54 03 38 41 11 10 73 28 31 84 26 14 26 VRCPTV6--222J-U 2.2K ohm VRCPTV6--472J-U 4.7K ohm 75 ohm VRCPTV6--750J-U 27K ohm VRCPTV6--273J-U VRCPTV6--122J-U 1.2K ohm VRCPTV6--472J-U 4.7K ohm 100 ohm VRCPTV6--101J-U 180 ohm VRNMK01--181J-VRCPTV6--122J-U 1.2K ohm 150 ohm VRCPTV6--151J-U 68K ohm VRCPTV6--683J-U VRMPTV6-7501F-U 7.5K ohm 22 ohm VRCPTV2--220J-U .82 ohm VRNMT02--R82J-.22 ohm VRNMK02--R22J-68K ohm VRCPTV6--683J-U 100 ohm VRNMT03--101J-56K ohm VRCPTV6--563J-U 10K ohm VRCPTV6--103J-U VRCPTV6--222J-U 2.2K ohm 22K ohm VRCPTV6--223J-U 6.8K ohm VRCPTV6--682J-U VRCPTV6--824J-U 820K ohm 680 ohm VRCPTV6--681J-U VRCPTV6--562J-U 5.6K ohm 560 ohm VRNMT03--561J-68K ohm VRCPTV6--683J-U VRCPTV2--682J-U 6.8K ohm 22K ohm VRCPTV6--223J-U 39 ohm VRNLQ03--390J-68 ohm VRNMT03--680J-.56 ohm VRNMK03--R56J-47 ohm VRCPTV4--470J-U 39 ohm VRNLQ05--561J-VRCPTV6--104J-U 100K ohm VRCPTV2--124J-U 120K ohm 33K ohm VRCPTV4--333J-U VRCPTV6--682J-U 6.8K ohm 220 ohm VRCPTV6--221J-U 22K ohm VRCPTV6--223J-U VRCPTV6--332J-U 3.3K ohm 12K ohm VRCPTV6--123J-U 68K ohm VRCPTV6--683J-U 82K ohm VRCPTV6--823J-U 47K ohm VRCPTV6--473J-U 10K ohm VRCPTV6--103J-U VRCPTV6--182J-U 1.8K ohm 560 ohm VRCPTV2--561J-U 12K ohm VRMPTV6-1202F-U VRMPTV6-9311F-U 9.31K ohm VRMPTV6-2701F-U 2.7K ohm VRCPTV4--104J-U 100K ohm 15K ohm VRCPTV6--153J-U 9-7 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1W 1/6W 1/6W 1/6W 1/6W 1/2W 2W 2W 1/6W 3W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 3W 1/6W 1/2W 1/6W 3W 3W 3W 1/4W 3W 1/6W 1/2W 1/4W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/2W 1/6W 1/6W 1/6W 1/4W 1/6W VER1.0 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1% 1% 1% 5% 5% Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Metal Oxide Film Metal Oxide Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Metal Oxide Film Metal Oxide Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Metal Film Metal Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST R646 R647 R652,673,689 R653,658,685 R654 R659,690 * R660,664 R661 R662,687,6P1 R663,651,683 R666,667 R670,6C4,6E3 R672 R674 R675 R676 R681 R682 R684,6H4 R686 * R688 R691 R692,697 R693 R694 R695 **** R696 R699 **** R6A2 **** R6A3 R6A5,6B6 R6A6 **** R6A7 * R6A8 **** R6A9 R6B1,6B2 R6B3 R6B7 60 13 35 11 02 34 25 86 68 10 72 76 58 38 14 17 35 83 78 84 75 79 07 54 37 79 35 30 75 55 89 30 13 71 30 62 50 28 R6B8,6F5,6G9 72 R6C1 11 R6C2,6D8 14 R6C3,6C7 58 R6C5 11 R6C6,6D7,6D9 41 R6C8 42 R6C9 56 R6D1 81 R6D2 51 R6D3,6D4 45 R6D5,6I4 13 R6D6 52 R6E1,6G7 41 VRMPTV6-1502F-U VRCPTV6--563J-U VRCPTV6--472J-U VRCPTV6--473J-U VRCPTV6--154J-U VRCPTV6--102J-U VRCPTV6--100J-U VRMPTV6-5902F-U VRCPTV6--124J-U VRCPTV6--103J-U VRCPTV6--223J-U VRCPTV6--393J-U VRCPTV6--101J-U VRMPTV4-8252F-U VRMPTV6-6812F-U VRMPTV6-4021F-U VRCPTV6--472J-U VRMPTV6-3482F-U VRCPTV6--331J-U VRCPTV6--753J-U VRCPTV6--104J-U VRMPTV6-4701F-U VRCPTV6--222J-U VRCPTV6--332J-U VRCPTV6--562J-U VRMPTV6-2492F-U VRCPTV6--472J-U VRCPTV6--333J-U VRMPTV6-1583F-U VRMPTV6-2493F-U VRCPTV6--821J-U VRNMK02--100J-VRCPTV6--563J-U VRCPTV6--335J-U VRCPTV6--333J-U VRCPTV4--102J-U VRNMK02--330J-VRCPTV6--560J-U VRCPTV6--223J-U VRCPTV6--392J-U VRCPTV4--104J-U VRCPTV4--333J-U VRCPTV6--473J-U VRCPTV6--823J-U VRCPTV2--104J-U VRCPTV2--1R0J-U VRCPTV2--184J-U VRCPTV6--273J-U VRCPTV2--564J-U VRCPTV6--563J-U VRCPTV6--242J-U VRCPTV6--823J-U 15K 56K 4.7K 47K 150K 1K 10 59K 120K 10K 22K 39K 100 82.5K 68.1K 4.02K 4.7K 34.8K 330 75K 100K 4.7K 2.2K 3.3K 5.6K 24.9K 4.7K 33K 158K 249K 820 10 56K 3.3M 33K 1K 33 56 22K 3.9K 100K 33K 47K 82K 100K 1 180K 27K 560K 56K 2.4K 82K ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm 9-8 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/4W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 2W 1/6W 1/6W 1/6W 1/4W 2W 1/6W 1/6W 1/6W 1/4W 1/4W 1/6W 1/6W 1/2W 1/2W 1/2W 1/6W 1/2W 1/6W 1/6W 1/6W VER1.0 1% 5% 5% 5% 5% 5% 5% 1% 5% 5% 5% 5% 5% 1% 1% 1% 5% 5% 5% 5% 5% 1% 5% 5% 5% 1% 5% 5% 1% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Metal Film Metal Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Metal Film Metal Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST **** **** **** **** **** R6E4,6E5,6F1 R6E6 R6E9,6K9 R6F3 R6F6 R6F9 R6G0 R6G1 R6G2 R6G3 R6G4 R6G5 R6G6 R6H0,6J2 R6H5 R6H6,6K2 R6H8 R6I0 R6I1 R6I2 R6I3 R6I5 R6I6,6K1,6K8 R6I8 R6I9 R6J0,6J1 R6J3 R6K3 R6K7 R6M1,6M2 R6P2 R6T1 R6T2 R6X1,6X2 R701 R702 R703,704 R706 R707,711,712 R708 R714,715 R716,717 R718 R719 R720,721 R722 R723 R724 R725 R726 R727,7P2 R728 R729,753 58 87 54 38 63 82 32 74 26 27 78 01 45 72 75 30 68 73 09 53 65 27 10 82 57 07 49 13 78 59 54 75 26 58 34 10 30 76 53 62 55 60 57 43 75 87 27 87 70 33 49 51 38 100 ohm VRCPTV6--101J-U 22 ohm VRCPTV6--220J-U VRCPTV6--332J-U 3.3K ohm VRMPTV6-6811F-U 6.81K ohm VRCPTV4--472J-U 4.7K ohm .18 ohm VRNMK01--R18J-390 ohm VRCPTV6--391G-U 511 ohm VRMPTV6-5110F-U 15K ohm VRCPTV6--153J-U VRCPTV6--274J-U 270K ohm VRCPTV6--564J-U 560K ohm 1K ohm VRCPTV2--102J-U VRNMK01--470J-47 ohm 22K ohm VRCPTV6--223J-U VRCPTV6--272J-U 2.7K ohm 33K ohm VRCPTV6--333J-U VRCPTV6--124J-U 120K ohm 3.9 ohm VRNMK02--3R9J-4.7 ohm VRNLQ03--4R7K-10 ohm VRNLQ03--100J-VRCPTV6--822J-U 8.2K ohm VRCPTV6--122J-U 1.2K ohm 10K ohm VRCPTV6--103J-U 604 ohm VRCPTV6-6040F-U VRCPTV6-2101F-U 2.1K ohm VRCPTV6--222J-U 2.2K ohm 18K ohm VRCPTV6--183J-U .56 ohm VRNMT03--R56J-2.2 ohm VRCPTV6--2R2J-U 470 ohm VRCPTV6--471J-U VRCPTV6--332J-U 3.3K ohm VRCPTV6--272J-U 2.7K ohm 1.5 ohm VRCPTV6--1R5J-U 100 ohm VRCPTV6--101J-U 1K ohm VRCPTV6--102J-U 10K ohm VRCPTV6--103J-U VRCPTV4--154J-U 150K ohm VRCPTV4--224J-U 220K ohm VRCPTV4--184J-U 180K ohm VRCPTV6--682J-U 6.8K ohm VRCPTV4--274J-U 270K ohm 82K ohm VRNMK01--823J-68K ohm VRNMK01--683J-68 ohm VRMMTV2--680J-U VRCPTV6--104J-U 100K ohm 22 ohm VRCPTV6--220J-U VRCPTV6--122J-U 1.2K ohm .22 ohm VRNMK03--R22J-.27 ohm VRNMK02--R27J-VRMPTV6-3012F-U 30.1K ohm 18K ohm VRCPTV6--183J-U 27K ohm VRCPTV6--273J-U 10K ohm VRCPTV4--103J-U 9-9 1/6W 1/6W 1/6W 1/6W 1/4W 1W 1/6W 1/6W 1/6W 1/6W 1/6W 1/2W 1W 1/6W 1/6W 1/6W 1/6W 2W 3W 3W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 3W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/6W 1/4W 1/4W 1/4W 1/6W 1/4W 1W 1W 1/2W 1/6W 1/6W 1/6W 3W 2W 1/6W 1/6W 1/6W 1/4W VER1.0 5% 5% 5% 1% 5% 5% 2% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 10% 5% 5% 5% 5% 1% 1% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1% 5% 5% 5% Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Metal Oxide Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Metal Oxide Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Metal Oxide Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Metal Oxide Film Metal Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Metal Oxide Film Metal Film Carbon Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST R730 R731,7A5 R732 R733 R734 R735 R736,741 R737,743 R738 R739 R740 R742 R748 R754,755 R756 R791 R793 R794 R7A2 R7A3 R7A4 R7A6 R7A7 R7A8 R7P1 RP97 RV81 **** **** **** **** **** **** **** **** **** 37 87 54 38 78 63 76 14 14 72 54 58 33 01 58 56 19 28 67 82 60 45 41 87 30 10 38 RL601,603,604 85 RL602 78 RL701 33 RGB181,182 07 RGB183 40 SG601 29 SO701 64 T601 26 T602 39 T603,604 68 T6C1 14 T6C2 42 T701 02 T702 10 T703 68 TH701 24 TH702 49 VR601 66 VR691 70 VR731 05 VZ701 40 X001 41 ZD001 64 ZD005,007 61 ZD101 61 QJUM-1039-1540U VRMPTV4-2673F-U VRCPTV4--153J-U VRCPTV6--683J-U VRCPTV4--152J-U VRCPTV4--472J-U VRCPTV6--393J-U VRCPTV4--104J-U VRCPTV6--202J-U VRCPTV6--223J-U VRCPTV6--332J-U VRCPTV4--333J-U RR-NZR18J-101-VRMPTV2--472J-U VRCPTV2--154J-U VRCPTV2--1R0J-U VRNMK01--1R0J-VRCPTV4--1R0J-U VRCPTV2--392J-U VRMPTV4-1002F-U VRMPTV4-7500F-U VRNMK01--153J-VRCPTV4--563J-U VRNMK01--3R9J-VRCPTV6--333J-U VRCPTV6--103J-U VRCPTV6--683J-U RRLYD1088-1DXGRRLYD1085-1DDGRRLYD1080-1PDGQSOCD1550-115-QSOCD1558-124-QSPG-1011-1---U QSOCP1042-12X-RTRND1060-1---RTRN-1060-1---RTRN-1059-1---RTRNF1006-1---DFBTCC150-1660RCVTP1381-1---RCILF1088-1---RCILF1080-1---VSH20S050M----VSQDGC2R9R0Q--RVRSH6032-1502RVRSH8003-8104RVRSH6032-1501VSVV14K300----RCRSL1045-1---VSZMTZJ5.1B---U VSZHZ5C1------U VSZHZ5C1------U VER1.0 Jumper 267K ohm 1/4W 1% Metal Film 15K ohm 1/4W 5% Carbon Film 68K ohm 1/6W 5% Carbon Film 1.5K ohm 1/4W 5% Carbon Film 4.7K ohm 1/4W 5% Carbon Film 39K ohm 1/6W 5% Carbon Film 100K ohm 1/4W 5% Carbon Film 2K ohm 1/6W 5% Carbon Film 22K ohm 1/6W 5% Carbon Film 3.3K ohm 1/6W 5% Carbon Film 33K ohm 1/4W 5% Carbon Film .18 ohm 1W 5% Metal Oxide Film 4.7K ohm 1/2W 5% Metal Film 150K ohm 1/2W 5% Carbon Film 1 ohm 1/2W 5% Carbon Film 1 ohm 1W 5% Metal Oxide Film 1 ohm 1/4W 5% Carbon Film 3.9K ohm 1/2W 5% Carbon Film 10K ohm 1/4W 1% Metal Film 75 ohm 1/4W 1% Metal Film 15K ohm 1W 5% Metal Oxide Film 56K ohm 1/4W 5% Carbon Film 3.9 ohm 1W 5% Metal Oxide Film 33K ohm 1/6W 5% Carbon Film 10K ohm 1/6W 5% Carbon Film 68K ohm 1/6W 5% Carbon Film Relay Relay Relay D-SUB 15P D-SUB 9P SPARK GAP Socket Horizontal Driver Transformer Transformer Transformer Dynamic Focus Transformer FBT Convert transformer Coil Coil Variable Resistor Variable Resistor Variable Resistor Crystal Zener Diode Zener Diode Zener Diode 9-10 5K ohm 100K ohm 500 ohm 12MHZ MTZJ5.1B HZ5C1 HZ5C1 SME-32DL5(P) ELECTRONIC PARTS LIST ZD110 ZD111~114 23 64 ZD102,123,125 64 ZD601,605,606 64 ZD603,604 80 ZD608 49 ZD611,612 80 ZD661,6C2 22 ZD6C1 35 ZD711,731 23 ZD712 70 ZD713 61 ZD7A1 54 “D” 02 “GND1,2” 50 62 “M” 62 “O” 03 “RO” 42 “U” 09 CV 80 HS 36 KH 82 TM 51 A 48 A1 57 DB 39 PI 77 VS 67 PO 12 FR1 57 RS 65 PS 46 21 43 04 03 13 76 68 85 31 64 58 60 84 89 57 07 36 77 14 16 VSZHZ12A1-----U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZHZ12C1-----U VSZMTZ9.1B----U VSZHZ12C1-----U VSZRD15EB3----U VSZHZ20-02----U VSZHZ12A1-----U VSZHZ18-2-----U VSZHZ5C1------U VSZMTZ6.8B----U QCNCP1547-1---QCNCP1517-1---VCNCP0022-----U VCNCP0022-----U QCNCP1542-1---QCNCP1540-1---VCNCP0305-EJSTQCNWS0046-1151QCNWS0047-1063QCNWS0049-1051QCNWS0306-1104QCNWS0307-1069QCNWS0303-1304QCNWS030B-1019QCNWS030A-1021QCNWS030B-1018QCNWS0044-1272QCNWS0309-1037QCNWS0305-1189QCNWS0303-1296GHLDP0068-1FD-QSW-A1199-11-1A QSW-A1198-11-1VSI93M2AKLSH--LANGF0729-1P--A LFIX-0016-1P--PCUSG0219-1---PCUSP0054-1---PCUSP0057-1---PCUSU0131-1---PISLM0015-1P--PRDAA0117-1P--I PRDAA0140-1P--B PRDAA0143-1P--PRDAA0143-1P--A PRDAA0164-1P--A PRDAA0170-1P--B PRDAA0171-1P--PRDAA0176-1P--B PRDAM0035-1P--- VER1.0 Zener Diode HZ12A1 Zener Diode MTZJ5.1B Zener Diode MTZJ5.1B Zener Diode MTZJ5.1B Zener Diode HZ12C1 Zener Diode MTZ9.1B Zener Diode HZ12C1 Zener Diode RD15EB3 Zener Diode HZ20-02 Zener Diode HZ12A1 Zener Diode HZ18-2 Zener Diode HZ5C1 Zener Diode MTZ6.8B Connector With Wire Connector With Wire Connector TH701 USE Connector Connector With Wire Connector With Wire Connector Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire LED HOLD FOR POWER, SAVING, STAND BY USE VOL +/-, MENU +/-, DEGAUSS, I/P SW POWER SW R/C RECEUVER AC & RS232 ANGLE FIX PLATE Silicon Rubber Q6I1 USE Silicon Rubber Q6C9,Q713 USE Silicon Rubber Q6I1 USE Cushion EVA FOR FBT Insulator Q604 USE RADIATOR Q6I1 USE RADIATOR Q665,Q6D4 USE RADIATOR D753,IC791,IC793, Q606,Q620 USE RADIATOR Q7A2 USE RADIATOR IC501 USE RADIATOR BR701,Q713 USE RADIATOR Q601,Q612,Q613 USE RADIATOR D603,Q604,6C9 USE RADIATOR D609,630,D755,D756 USE 9-11 SME-32DL5(P) ELECTRONIC PARTS LIST 71 71 65 08 76 46 39 QFSHC1017-1---P QJAKM1076-1---QPINR1069-1---QSOCI1177-108-QSOCI1517-142-XBPSD30P06000-XBPSD30P10000-- 58 74 77 82 66 XEASD30P10000-XHISE40P08TV0-XJASD30P10000-XJJSD30P10000-XLMAZ32-89000-- VER1.0 F701 USE RGB-Audio jack PIN R503,507,603,609,6K3 USE IC socket IC002 USE IC socket IC001 USE SCREW PRDAA0171*3 USE SCREW D753,IC791,IC793,Q606,Q620,Q665,Q6D4,Q7A2 USE SCREW FBT*2 SCREW LANGF0729*1 SCREW Q6I1,PRDAA0170*2,PRDAA0176*4 USE SCREW IC501*2 USE SCREW SO701 USE 9-12 SME-32DL5(P) ELECTRONIC PARTS LIST **** **** 87 52 26 19 77 33 34 56 67 43 84 45 45 02 70 27 09 10 18 58 48 88 81 07 61 16 44 82 56 59 02 37 01 58 61 40 22 87 24 67 79 18 16 61 23 29 03 08 41 29 59 40 56 BRC-229B------DBOXS0014-1FD-S DCABA0226-1FD-W GBOX-0008-1FD-B GBOXS0014-1FD-B GCABA0226-1FD-F GCABB0268-1FD-GCOVS0008-1FD-B GDORP0199-1F--GNETP0014-1P--HBDGA0090-1---HDECP0362-1F--D HINDP0364-1P--B HINDP0374-1P--JHNDP0020-1---JKNBP0510-1F--C JKNBP0511-1F--LANGS0056-1P--B LCHSP0023-1F--A LFIX-0017-1P--LHLD-0180-1---LHLDW0094-1---MSPR-0003-1---PCUSS0056-1Z--PCUSS0061-1---A PMAG-1108-1A--PREFL0010-1F--B PSLD-0008-1P--B PSLDM0276-1P--C PSPAG0020-1---A PSPAG0020-1---PWABS0027-1---PWABS0029-1---PWABS0029-1---A PWABS0030-1---PWABS0031-1---PWABS0032-1---QACCF1063-1DX-QCODS1039-1D--QPLGR1199-1---QTMLA1113-1F—I RBATB0213-1DC-RCILG1078-1---RCILQ1019-1---A RSPKER086-18TNRSPKKS087-18WNA SPAKA0579-1F--SPAKC0623-1R-AO SPAKH0079-1FW-E SSAKD0003-1---SSAKH0097-1---TINSE1952-1---TLABD1025-1B--A R/C SPK BOX CAB-A ASSEMBLY DOME SPK GUIDE DOME SPK BOX CAB-A REAR CAB GUIDE COVER DOOR PET "PICTURE-TEL” MARK AV FUNCTION PANEL IND-P TRANSPARENCY FOR FBT HANDLE SET POWER KNOB FUNCTION KNOB ANGLE FOR SPK FIX CHASSIS FIX PLATE DOOR LOCKER ROTATION COIL SPRING FOR CRT DOME SPK*2 SPONGE FOR CRT SHIELD CRT USE REF FOR RC&LED SHIELD-P FOR IC001 CRT PWB BOX CRT SPACER WAVE ABSOPTION GBOX-0008(L*2, R*2) WAVE ABSOPTION GBOXS0008(L*1, R*1) WAVE ABSOPTION GBOXS0008(L*1, R*1) WAVE ABSOPTION GBOX-0008 (L*1, R*1) WAVE ABSOPTION DOME SPK WABS WAVE ABSOPTION GBOX-0008 (L*1, R*1) AC CORD SIGNAL CABLE AUDIO CABLE ANT PANEL BATTERY (3) DEGAUSSING COIL ROTATION COIL SPEAKER SPK L-HI,R-HI SPK L-LOW, R-LOW PACKING AD PACKING CASE HOSO-PP PE BAG (MANUAL) POLY BAG USER MANUAL BAR CODE 9-13 VER1.0 SME-32DL5(P) ELECTRONIC PARTS LIST **** 14 41 87 08 44 64 42 73 25 34 64 13 47 74 59 58 TLABD1109-1B--TLABM1142-1---VBM81AHM50X01-A XETSD40P30000-XETSD40P10000-XTTSB40P16000-TMAPT1004-1---ZSTPL-MAX10-1MXEASD30P08000-XNESD80-65000-XWTSD82-20154-LX-WZ0019-1---XTTSD30P12000-XHISE40P08TV0-XESSB30P12000-XEASD30P10000-- 35 11 37 30 XEASD30P12000-XETSD40P08000-PCAPH0005-1F--XETSD40P16000-- 08 47 77 78 XETSD40P30000-XHSSB30P12000-XJASD30P10000-XJSSB30P12000-- VER1.0 WATING LABEL (NOTICE DAN GERS) MODEL LABEL CRT SCREW CAB-AB*8 SCREW SPK FIX SCREW QTMLA*4,CAB*2 INSTALL SKETCH DATA SPK*4 M8 NUT FOR CRT SCREW SPRING WASHER FOR CRT WASHER FOR CRT CHASS & CAB-A FIX LANGF0729*1 ANT PANEL & CHASSIS*5,HDECP0362 & AV BOARD*7 SCREW MAIN PWB*9, TWEETER*4, FIX POWER PWB, FUNCTION CHASSIS*2,LIGHT GUIDE, DAMPER,PLATE*2 FIX LFIX-0017 VM PWB*2 VR COVER SCREW GCOVS0008 & GCOV-0008 FIX,CAB-A & DOME*8, ANG & DOME SPK*8 SCREW CRT HOLD SCREW LANGP0182*3 SCREW PRDAA0170*2,PRDAA0117*2,PRADD0164*2, SCREW AC CORD*2 9-14 SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 2.AUDIO POWER BOARD G PWB C301,308,312 C302,307 C303,306 C304,305 C309,311 C310 C313,315 C318 C321 C322~324 C327,331 C328,333 C329,334 C332,342 C338,340 C339,341 C343,356,357 C345,347 C346 C351,352 C358,359 C366,367 C368 C374,375 C376 C385 C386 C387,388 C780 C781 C782 C783 C784 C785 * C786,787 C788 C789 C790 C791 C792,795 C798 C799 D301~309,316 D786 D788 D789 D790 F301 16 78 15 50 13 53 85 19 50 45 77 05 32 74 53 60 13 57 53 21 32 83 17 85 17 02 77 29 13 28 26 20 23 12 38 61 62 73 79 37 77 44 17 89 50 30 73 37 81 QPWB51059-1B-3VCEACU1HG475M-P VCEACU1HG564M-P VCPELU1HG822J-P VCEACU1HG474M-P VCEACU1HG106M-P VCPELU1HG473J-P VCENCU1CG106M-P VCEACU1HG225M-P VCEACU1CG476M-P VCEACU1HG105M-P VCDCDU1HH560J-P VCEACU1HG334M-P VCEACU1HG224M-P VCEACU1HG106M-P VCPELU1HG104J-P VCEACU1HG474M-P VCPELU1HG223J-P VCPELU1HG124J-P VCEACU1CG477M-P VCEACU1HG334M-P VCEACU1VG108M-P VCKBDU1HY222K-P VCEACU1CG108M-P VCKBDU1HY222K-P VCEACU1HG227M-P VCEACU1EG107M-P VCEACU1HG107M-P VCEACU1HG474M-P VCEACU2GG226M-VCEACU1HG226M-P VCPELU1HG472J-P VCPELU1HG683J-P VCEACU1HG104M-P VCPPHF2JG183J-VCKEDF7GY472MX3 VCRRDF3DY471K-VCEACF1HG338M-VCSFDU1HY104Z-P VCRRDF3DY102K-VCEACU1EG107M-P VCKBDU1HY102K-P VCKBDU1HY222K-P VSD1N4148-----U VSDFR103------U VSDUR1K-------U VSDSUF30J-----U VSDSF16-------U QFS-D202F-12X-- POWER / SOUND AMP BOARD 4.7uF 50V ±20% Aluminum Elect. .56uF 50V ±20% Aluminum Elect. 8200PF 50V ±5% Polypropylene Film .47uF 50V ±20% Aluminum Elect. 10uF 50V ±20% Aluminum Elect. .047uF 50V ±5% Polypropylene Film 10uF 16V ±20% Aluminum Elect. 2.2uF 50V ±20% Aluminum Elect. 47uF 16V ±20% Aluminum Elect. 1uF 50V ±20% Aluminum Elect. 56PF 50V ±20% Temp. Comp. Ceramic .33uF 50V ±20% Aluminum Elect. .22uF 50V ±20% Aluminum Elect. 10uF 50V ±20% Aluminum Elect. .1uF 50V ±5% Polypropylene Film .47uF 50V ±20% Aluminum Elect. .022uF 50V ±5% Polypropylene Film .12uF 50V ±5% Polypropylene Film 470uF 16V ±20% Aluminum Elect. .33uF 50V ±20% Aluminum Elect. 1000uF 35V ±20% Aluminum Elect. 2200PF 50V ±10% High Diel. Ceramic 1000uF 16V ±20% Aluminum Elect. 2200PF 50V ±10% High Diel. Ceramic 220uF 50V ±20% Aluminum Elect. 100uF 25V ±20% Aluminum Elect. 100uF 50V ±20% Aluminum Elect. .47uF 50V ±20% Aluminum Elect. 22uF 400V ±20% Aluminum Elect. 22uF 50V ±20% Aluminum Elect. 4700PF 50V ±5% Polypropylene Film .068uF 50V ±5% Polypropylene Film .1uF 50V ±20% Aluminum Elect. .018uF 630V ±5% Polypropylene Film 4700PF AC400V ±20% High Diel. Ceramic 470PF 2KV ±10% High Dielectric Ceramic 3300uF 50V ±20% Aluminum Elect. .1uF 50V +80%-20% Semiconductor Ceramic 1000PF 2KV ±10% High Dielectric Ceramic 100uF 25V ±20% Aluminum Elect. 1000PF 50V ±10% High Diel. Ceramic 2200PF 50V ±10% High Diel. Ceramic Diode 1N4148 Diode FR103 Diode UR1K Diode SUF30J Diode SF16 Fuse 2A/250V 9-15 SME-32DL5(P) ELECTRONIC PARTS LIST FB781 FB782 FB783~788 GND2 IC301 IC302 IC303~309 IC310 IC311 IC716 * IC717 IC781 IC782 LO Q301,302,304 Q303 R301,305 R302 R303,307,308 R304,306 R309 R310,311 R312~317 R318,343,368 R322,327 R323,326 R324,325 R328,329,333 R330~332 R334,335 R336,337 R338~341 R342,379, R344,345,347 R346,348 R349,353,354 R350,355 R351,352,356 R357,358 R359,360,363 R361,362,364 R365,366 R367 R369 R370 R371 R372,373 R374,375 R376,383 R377,381,385 R378 R380 R382,384,390 32 80 78 67 27 52 20 68 89 84 15 38 89 12 82 01 35 08 72 34 41 34 11 30 11 03 65 10 11 65 11 03 13 34 62 35 11 65 75 35 10 35 65 10 54 78 11 11 34 30 02 07 13 RCORA1025-1---U RCORA1004-1---U RCORA1026-1---U QCNWS0651-1067VSITA8184P----VSIMC14066BCP-VSINJM4558D---VSINJM2904D---VSITDA2616----VSIVIPER100---VSIPC817C-----VSILM2940CT5--VSITL431CZ----P QCNWS0092-1037VSIDTC144ES---P VST2SC1815Y---P VRCPTV6--472J-U VRNMK01--2R2J-VRCPTV6--223J-U VRCPTV6--102J-U VRCPTV6--823J-U VRCPTV6--102J-U VRCPTV6--473J-U VRCPTV6--333J-U VRCPTV6--392J-U VRCPTV6--123J-U VRCPTV6--822J-U VRCPTV6--103J-U VRCPTV6--392J-U VRCPTV6--822J-U VRCPTV6--392J-U VRCPTV6--123J-U VRCPTV6--563J-U VRCPTV6--102J-U VRCPTV6--682J-U VRCPTV6--472J-U VRCPTV6--392J-U VRCPTV6--822J-U VRCPTV6--272J-U VRCPTV6--472J-U VRCPTV6--103J-U VRCPTV6--472J-U VRCPTV6--822J-U VRCPTV6--103J-U VRCPTV6--332J-U VRCPTV6--564J-U VRCPTV6--392J-U VRCPTV6--473J-U VRCPTV6--102J-U VRCPTV6--333J-U VRCPTV6--154J-U VRCPTV6--222J-U VRCPTV6--563J-U Core Core Core Connector With Wire IC TA8184P IC MC14066BCP IC NJM4558D IC NJM2904D IC TDA2616 IC VIPER100 IC PC817C IC LM2940CT5 IC TL431CZ Connector With Wire IC DTC144ES Transistor 2SC1815Y 4.7K ohm 1/6W 5% Carbon Film 2.2 ohm 1W 5% Metal Oxide Film 22K ohm 1/6W 5% Carbon Film 1K ohm 1/6W 5% Carbon Film 82K ohm 1/6W 5% Carbon Film 1K ohm 1/6W 5% Carbon Film 47K ohm 1/6W 5% Carbon Film 33K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 12K ohm 1/6W 5% Carbon Film 8.2K ohm 1/6W 5% Carbon Film 10K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 8.2K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 12K ohm 1/6W 5% Carbon Film 56K ohm 1/6W 5% Carbon Film 1K ohm 1/6W 5% Carbon Film 6.8K ohm 1/6W 5% Carbon Film 4.7K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 8.2K ohm 1/6W 5% Carbon Film 2.7K ohm 1/6W 5% Carbon Film 4.7K ohm 1/6W 5% Carbon Film 10K ohm 1/6W 5% Carbon Film 4.7K ohm 1/6W 5% Carbon Film 8.2K ohm 1/6W 5% Carbon Film 10K ohm 1/6W 5% Carbon Film 3.3K ohm 1/6W 5% Carbon Film 560K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 47K ohm 1/6W 5% Carbon Film 1K ohm 1/6W 5% Carbon Film 33K ohm 1/6W 5% Carbon Film 150K ohm 1/6W 5% Carbon Film 2.2K ohm 1/6W 5% Carbon Film 56K ohm 1/6W 5% Carbon Film 9-16 VER1.0 SME-32DL5(P) ELECTRONIC PARTS LIST R386,387 R388,389 R393,394 R397,398 R399,3C8 R3A0,3A1 R3A2,3A3 R3A4,R3A7 R784 R785 R786 R787 R790 R792 R794 R795 R797 SF * T781 ZD781 “A” “A1” “D” “GND”GND1” 12 73 26 75 75 73 65 75 34 11 62 31 60 35 76 01 72 18 77 78 62 45 02 50 01 72 48 59 89 71 39 77 82 VRNMK02--R22J-VRCPTV6--182J-U VRCPTV6--153J-U VRCPTV4--8R2J-U VRCPTV6--272J-U VRCPTV6--182J-U VRCPTV6--822J-U VRCPTV6--104J-U VRCPTV6--102J-U VRCPTV6--392J-U VRMPTV2--4R7J-U VRNMK02--153J-VRNMK01--150J-VRCPTV6--472J-U VRCPTV6--393J-U VRMPTV2--472J-U VRCPTV6--223J-U QCNWS0303-1297RCVTP1397-1-U-VSZMTZ3.9B----U VCNCP0307-EJSTVCNCP0303-EJSTQCNCP1547-1---QCNCP1517-1---LANGF0777-1P--LANGF0778-1P--PRDAA0025-1P--V PRDAA0032-1A--H PRDAA0143-1P--QFSHC1017-1---P XBPSD30P10000-XJASD30P10000-XJJSD30P10000-- .22 ohm 2W 5% Metal Oxide Film 1.8K ohm 1/6W 5% Carbon Film 15K ohm 1/6W 5% Carbon Film 8.2 ohm 1/4W 5% Carbon Film 2.7K ohm 1/6W 5% Carbon Film 1.8K ohm 1/6W 5% Carbon Film 8.2K ohm 1/6W 5% Carbon Film 100K ohm 1/6W 5% Carbon Film 1K ohm 1/6W 5% Carbon Film 3.9K ohm 1/6W 5% Carbon Film 4.7 ohm 1/2W 5% Metal Film 15K ohm 2W 5% Metal Oxide Film 15 ohm 1W 5% Metal Oxide Film 4.7K ohm 1/6W 5% Carbon Film 39K ohm 1/6W 5% Carbon Film 4.7K ohm 1/2W 5% Metal Film 22K ohm 1/6W 5% Carbon Film Connector With Wire Convert Transformer Zener Diode MTZ3.9B Connector Connector Connector With Wire Connector With Wire QPWB51059*1 ANGLE QPWB51059*1 ANGLE RADIATOR IC311 USE RADIATOR IC716 USE RADIATOR IC781 USE PIN F301 USE SCREW IC781 USE SCREW IC716*1 SCREW IC311*2 9-17 VER1.0 SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 3.CRT BOARD CRT PWB C901,903,904 C902,908,910 C905,907,915 C906 C909,914 C911,913,916 C912 C917 C921,925,926 C922 C924 C971 C972 C973 D901~908 D909~911 D971 FB901~903 FB904,905 IC901 L901 L902,972,974 L971,973,975 Q901 Q902,904,906 Q903,905,907 Q908,972,974 Q909,971,973 Q910 R901~904 R905 R906~908 R909,912 R910,913,915 R911,914,916 R917~919 R920,921 R922,924 R923,956 R925 R926,933,940 R927 R928,935,942 R929 R930,934,939 R931,937,944 R932,938,945 R936 R941,946 R943 12 12 20 20 53 45 20 69 13 20 54 74 87 84 26 89 12 74 15 27 12 20 21 13 61 01 46 15 46 87 10 58 58 51 53 07 58 31 51 26 49 35 53 74 32 53 53 55 18 53 87 QPWB51022-1B-3VCEACU1HG104M-P VCEACU1CG107M-P VCKBDU1HY103K-P VCEACU1HG106M-P VCKBDU1HY391K-P VCEACU1CG107M-P VCKBDU1HY471K-P VCEACU1EG476M-P VCKBDU1HY103K-P VCKBDF2HY103K-VCEACU1HG224M-P VCEACU2EG106M-P VCEACU2EG225M-P VCKBEF3DY103Z-VSD1N4148-----U VSD1SS83------U VSD1N4002-----U RCORA1021-1---U RCORA1033-1---VSITDA4885----VL-PH100K0000-P VL-PH470K0000-P VL-NH3R3K0000-P VST2SC2482----VST2SC1815Y---P VST2SC3790E---VST2SA1480E---VST2SC3790E---VST2SA1015Y---P VRCPTV6--103J-U VRCPTV6--101J-U VRCPTV6--101J-U VRCPTV6--121J-U VRCPTV6--680J-U VRCPTV6--222J-U VRCPTV6--101J-U VRCPTV6--221J-U VRCPTV6--121J-U VRCPTV6--153J-U VRCPTV6--183J-U VRCPTV6--472J-U VRCPTV6--680J-U VRCPTV6--151J-U VRCPTV6--6R8J-U VRCPTV6--680J-U VRCPTV4--184J-U VRMPTV6-5761F-U VRCPTV6--120J-U VRCPTV6--680J-U VRCPTV6--220J-U CRT BOARD .01uF 50V ±20% 100uF 16V ±20% .01uF 50V ±10% 10uF 50V ±20% 390PF 50V ±10% 100uF 16V ±20% 470PF 50V ±10% 47uF 25V ±20% .01uF 50V ±10% .01uF 500V ±10% .22uF 50V ±20% 10uF 250V ±20% 2.2uF 250V ±20% .01uF 2KV +80%-20% Diode 1N4148 Diode 1SS83 Diode 1N4002 Bead cord Bead cord IC TDA4885 Peaking Coil 10uH Peaking Coil 47uH Peaking Coil 3.3uH Transistor 2SC2482 Transistor 2SC1815Y Transistor 2SC3790E Transistor 2SA1480E Transistor 2SC3790E Transistor 2SA1015Y 10K ohm 1/6W 5% 100 ohm 1/6W 5% 100 ohm 1/6W 5% 120 ohm 1/6W 5% 68 ohm 1/6W 5% 2.2K ohm 1/6W 5% 100 ohm 1/6W 5% 220 ohm 1/6W 5% 120 ohm 1/6W 5% 15K ohm 1/6W 5% 18K ohm 1/6W 5% 4.7K ohm 1/6W 5% 68 ohm 1/6W 5% 150 ohm 1/6W 5% 6.8 ohm 1/6W 5% 68 ohm 1/6W 5% 180K ohm 1/4W 5% 5.76K ohm 1/6W 1% 12 ohm 1/6W 5% 68 ohm 1/6W 5% 22 ohm 1/6W 5% 9-18 Aluminum Elect. Aluminum Elect. High Diel. Ceramic Aluminum Elect. Temp. Comp. Ceramic Aluminum Elect. Temp. Comp. Ceramic Aluminum Elect. High Diel. Ceramic High Diel. Ceramic Aluminum Elect. Aluminum Elect. Aluminum Elect. High Diel. Ceramic Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST **** R947,948 R949,976,984 R950~952 R953,954,957 R955 R961~963 R971,980,988 R972,979,987 R973~975 R977,978 R981~983 R985,986 R989 R990 R991 R993 SG974 SG971~973 SG975 VR901 “CV” “G” “HS” “KH” “PO” 05 53 31 10 30 31 82 62 31 05 31 05 62 24 69 80 13 82 50 41 18 09 68 80 44 45 53 39 44 VRCPTV4--270J-U VRCPTV4--100J-U VRNMK02--153J-VRCPTV6--103J-U VRCPTV6--333J-U VRCPTV6--221J-U VRCPTV2--470J-U VRCPTV6--682J-U VRNMK02--153J-VRCPTV4--270J-U VRNMK02--153J-VRCPTV4--270J-U VRCPTV4--102J-U VRCPTV6--225J-U VRCPTV2--563J-U RR-HZ106M-1V4-QSPG-1009-1---U QSPG-1013-1---U QSPG-1010-1---U RVRSVF001-1206QSOCC1334-112-VCNCP0046-JJSTVCNCP0102-PJSTVCNCP0047-JJSTVCNCP0049-JJSTVCNCP0044-JJSTPRDAA0140-1P--F XBPSD30P10000-XJASD30P08000-- 27 ohm 10 ohm 15K ohm 10K ohm 33K ohm 220 ohm 47 ohm 6.8K ohm 15K ohm 27 ohm 15K ohm 27 ohm 1K ohm 2.2M ohm 56K ohm 10M ohm Spark Gap Spark Gap Spark Gap 1/4W 1/4W 2W 1/6W 1/6W 1/6W 1/6W 1/6W 2W 1/4W 2W 1/4W 1/6W 1/6W 1/2W 1/4W VER1.0 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 20% Carbon Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Oxide Film Carbon Film Metal Oxide Film Carbon Film Carbon Film Carbon Film Carbon Film H.V. Resistance CRT SOCKET Connector Connector Connector Connector Connector RADIATOR Q903,905,907 USE SCREW Q903,905,907 USE SCREW AUDIO PWB & ANGLE*2 USE 9-19 SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 4. VM BOARD VM PWB CV1,V13 CV6 CV7 CV8 CV09 CV10,V11 CV12 CV14,V16 CV15,V17 CV18,19 CV21 CV22,V23 DV1~V4 DV5,V6 DV7,V8 FBV1,V2 QV10 QV11 QV12 QV2,V4~V9 RV3 RV6,V43 RV10 RV11 RV12 RV13 RV14,V28,V33 RV15 RV16,V17 RV18 RV19 RV20 RV21,V22,V24 RV23 RV25 RV26,V27 RV29,V34 RV30,V31 RV32 RV35,V36 RV37,V38 RV39 RV40 RV41 RV42 U U1 “U” 13 45 50 71 09 79 50 44 79 75 15 31 14 89 39 61 15 87 25 36 01 61 72 07 34 25 86 50 28 11 76 13 65 07 10 80 56 27 38 03 83 13 83 16 30 51 02 46 63 70 44 QPWB11275-1BA2- VM PWB 47uF 16V VCEACU1CG476M-P ±20% VCPELU1HG822J-P 8200PF 50V ±5% VCKBDU1HY561K-P 560PF 50V ±10% VCKFDU1HY103Z-P .01uF 50V ±20% +80%-20% VCSFDU1HY104Z-P .01uF 50V VCEACU1HG225M-P 2.2uF 50V ±20% VCKBDU1HY102K-P 1000PF 50V ±10% VCKBDF2HY472K-- 4700PF 500V ±10% VCDSDU1HL101J-P 100PF 50V ±5% 47uF 200V VCEACU2DG476M-P ±20% 56PF 50V VCDSDU2HL560J-P ±5% VCEACU2DG106M-P 10uF 200V ±20% 1N4148 VSD1N4148-----U Diode 1SS11914TA VSD1SS11914TA-U Diode RH1S VSDRH1S-------- Diode RCORA1021-1---- Bead cord 2SC1015Y VST2SA1015Y---P Transistor 2SC1837 VST2SC1837----- Transistor 2SC4793 VST2SC4793----- Transistor 2SC1815Y VST2SC1815Y---P Transistor 560 ohm 1/6W 5% VRCPTV6--561J-U 22K ohm 1/6W 5% VRCPTV6--223J-U 2.2K ohm 1/6W 5% VRCPTV6--222J-U 1K ohm 1/6W 5% VRCPTV6--102J-U 470 ohm 1/6W 5% VRCPTV6--471J-U 680 ohm 1/6W 5% VRCPTV6--681J-U 1.5K ohm 1/6W 5% VRCPTV6--152J-U 56 ohm 1/6W 5% VRCPTV6--560J-U 3.9K ohm 1/6W 5% VRCPTV6--392J-U 39K ohm 1/6W 5% VRCPTV6--393J-U 56K ohm 1/6W 5% VRCPTV6--563J-U VRCPTV6--822J-U 8.2K ohm 1/6W 5% 2.2K ohm 1/6W 5% VRCPTV6--222J-U 10K ohm 1/6W 5% VRCPTV6--103J-U 10 ohm 1/2W 5% VRMPTV2--100J-U 82 ohm 1/6W 5% VRCPTV6--820J-U 1.2K ohm 1/6W 5% VRCPTV6--122J-U 68K ohm 1/6W 5% VRCPTV6--683J-U 12K ohm 1/6W 5% VRCPTV6--123J-U 56 ohm 1/2W 5% VRMPTV2--560J-U 2.7 ohm 1/2W 5% VRMPTV2--2R7J-U 330 ohm 1/2W 5% VRNMK02--331J-3.9K ohm 2W 5% VRNMK02--392J-33K ohm 1/6W 5% VRCPTV6--333J-U 27K ohm 1/6W 5% VRCPTV6--273J-U QCNWS0305-1179- Connector With Wire QCNWS0302-1290- Connector With Wire VCNCP0302-EJST- Connector PRDAM0032-1P--- RADIATOR QV11,V12 USE XJASD30P08000-- QV11,V12 USE 9-20 Aluminum Elect. Polypropylene Film High Diel. Ceramic High Diel. Ceramic Semiconductor Ceramic Aluminum Elect. High Diel. Ceramic High Diel. Ceramic Temp. Comp. Ceramic Aluminum Elect. Temp. Comp. Ceramic Aluminum Elect. Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Metal Film Metal Film Metal Oxide Film Metal Oxide Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 5.AV & YUV BOARD AV & YUV 73 QPWB51087-1G--- AV & YUV PWB C802,803,804 53 VCEACU1HG106M-P 10uF 50V C806,807,808 53 VCEACU1HG106M-P 10uF 50V C809,810,812 53 VCEACU1HG106M-P 10uF 50V C811 21 VCEACU1CG477M-P 470uF 16V C813,827,828 53 VCEACU1HG106M-P 10uF 10uF 50V C814,801,817 53 VCEACU1HG106M-P 10uF 50V C816,805,815 53 VCEACU1HG106M-P 10uF 50V C818,887,8A5 45 VCEACU1CG476M-P 47uF 16V C821,8C9 28 VCDCDU1HH121J-P 120P 50V C822 22 VCDCDU1HH330J-P 33P 50V 1uF 50V C823,880,8M5 77 VCEACU1HG105M-P C824,820 68 VCDCDU1HH390J-P 39P 50V C832,846,847 53 VCEACU1HG106M-P 10uF 50V 53 VCEACU1HG106M-P 10uF 50V C833,834,831 C835,837,838 38 VCLRHN1HB103K-A 0.01uF 50V C839,840,850 38 VCLRHN1HB103K-A 0.01uF 50V C841,8M1,8A2 53 VCEACU1HG106M-P 10uF 50V C842,843,845 77 VCEACU1HG105M-P 1uF 50V C848,851 53 VCEACU1HG106M-P 10uF 50V C849,8N7,8P6 53 VCEACU1HG106M-P 10uF 50V C854 84 VCDCDU1HH120J-P 12P 50V C855 18 VCDCDU1HH150J-P 150P 50V C856 81 VCPELU1HG222J-P 2200PF 50V C857 74 VCEACU1HG224M-P 0.22uF 50V C858,864,875 38 VCLRHN1HB103K-A 0.01uF 50V C859 40 VCEACU1CG337M-P 330uF 16V C860 18 VCMECU1JG104J-P 0.1uF 63V C861,866,870 50 VCEACU1HG225M-P 2.2uF 50V C862,867,876 20 VCEACU1CG107M-P 100uF 16V C863 64 VCDCDU1HH220J-P 220P 50V C865 57 VCPELU1HG223J-P 0.022uF 50V C868 71 VCKBDU1HY561K-P 560PF 50V C869,8V3,8V4 78 VCEACU1HG475M-P 4.7uF 50V C871,879,884 50 VCEACU1HG225M-P 2.2uF 50V C871,879,884 C872,873,874 12 VCEACU1HG104M-P 0.1uF 50V C877 77 VCEACU1HG105M-P 1uF 50V C878,8A3,8C6 20 VCEACU1CG107M-P 100uF 16V C881,882,883 18 VCMECU1JG104J-P 0.1uF 63V 2.2uF 50V C885,8A0,8V1 50 VCEACU1HG225M-P 0.01uF 50V C886,8A1,8C0 38 VCLRHN1HB103K-A C888 17 VCKBDU1HY222K-P 2200PF 50V C890,891,836 18 VCKBDU1HY181K-P 180PF 50V C890,891,836 C8A4 35 VCDCDU1HH101J-P 100P 50V C8A7 69 VCKBDU1HY471K-P 470PF 50V C8C1,8C4,8C5 38 VCLRHN1HB103K-A 0.01uF 50V C8C2,8C3,844 22uF 16V C8C2,8C3,844 17 VCEACU1CG226M-P C8C7,8N4,8P1 20 VCEACU1CG107M-P 100uF 16V C8C8,8N8 38 VCLRHN1HB103K-A 0.01uF 50V C8E1,8E2,8E3 33 VCICHN1HH220J-A 22PF 50V C8E4,8E5,8E6 04 VCICHN1HH101J-A 100PF 50V C8J4,8J5,8J6 05 VCLRHN1CB104K-A 0.1uF 16V C8J7,8J8,8J9 05 VCLRHN1CB104K-A 0.1uF 16V C8K0,8K1 44 VCKBDU1HY102K-P 1000PF 50V 9-21 20% ±20% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 5% ±5% 5% ±5% ±20% 5% ±5% 20% ±20% 20% ±20% 10% ±10% 10% ±10% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 5% ±5% 5% ±5% 5% ±5% 20% ±20% 10% ±10% 20% ±20% 5% ±5% 20% ±20% 20% ±20% 5% ±5% 5% ±5% 10% ±10% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 5% ±5% 20% ±20% 10% ±10% 10% ±10% 10% ±10% 5% ±5% 10% ±10% 10% ±10% 20% ±20% 20% ±20% 10% ±10% 5% ±5% 5% ±5% 10% ±10% 10% ±10% 10% ±10% Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Temp. Comp. Ceramic Temp. Comp. Ceramic Aluminum Elect Temp. Comp. Ceramic Aluminum Al uminum Elect Aluminum Elect High Diel. Chip Capacitor High Diel. Chip Capacitor Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Temp. Comp. Ceramic Temp. Comp. Ceramic Polypropylene Film Aluminum Elect High Diel. Diel . Chip Capacitor Aluminum Elect Metal Ploy. Film Aluminum Elect Aluminum Elect Elect Temp. Comp. Ceramic Polypropylene Film High Diel. Ceramic Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect Metal Ploy. Film Aluminum Elect High Diel. Chip Capacitor High Diel. Ceramic High Diel. Ceramic Temp. Comp. Ceramic High Diel. Ceramic High Diel. Chip Capacitor Aluminum Elect Aluminum Elect High Diel. Chip Capacitor High Diel. Chip Chip Capacitor High Diel. Chip Capacitor High Diel. Chip Capacitor High Diel. Chip Capacitor High Diel. Ceramic SME-32DL5(P) ELECTRONIC PARTS LIST C8M0,8M3 C8M2,8M4 C8M6,8M7 C8M8,8M9 C8N0,8N1,8N2 C8N5,8N6 C8P2,819,889 C8P3,8V2 C8P3,8V2 C8P4 C8P8,8V5 CY02 D801,802,803 D804,805,806 D807,808,809 D810 D811 IC801 IC802 IC802 IC804 IC804,805 IC805 IC806 IC807 IC808,809 IC810 IC812 IC813 IC814 IC816 IC8V1 L801,802,805 L803 L804 L806 L807 PWB PWB Q801,802,803 Q804,809,810 Q805,806,807 Q811,812,819 Q813,814,815 Q816,831 Q818 Q820,821 Q822,832 Q8V1,8V2 R801,808,818 R802,807,809 R803,805,814 R804,811,813 R810,812,828 R815,838,841 R816,837,840 R817,806 R819 45 13 77 75 05 33 82 20 82 53 60 19 19 19 19 19 63 57 84 30 81 08 05 34 43 57 26 70 14 28 43 67 28 67 48 01 01 82 82 87 01 87 19 82 86 33 81 09 58 09 58 09 35 08 VCEACU1CG476M-P VCEACU1HG474M-P VCEACU1HG105M-P VCLFHN1CY474M-A VCLRHN1CB104K-A VCICHN1HH220J-A VCEACU1CG227M-P VCEACU1CG107M-P VCEACU1CG227M-P VCEACU1HG106M-P VCICHN1HH100J-A VSDRLS4148----A VSDRLS4148----A VSDRLS4148----A VSDRLS4148----A VSDRLS4148----A VSITA1276AN---VSIM52055FP---A VSINJM7805FA--ZSLCN-SG841---VSINJM7809FA--VSIM52472P----VSITC9090AN---VSIHEF4052BT--A VSINJM2234D---VSI74HC4538D--A VSIM52055FP---A VSI74LS125----A VSITA8772AN---VSIUPC1406----VL-DH101K0000-U VL-DH150K0000-U VL-DH100K0000-U VL-DH101K0000-U VL-DH100K0000-U ZSOLDW500-1R6-VST2SC1815Y---P VST2SC1815Y---P VSIDTC144ES---P VSIDTC144ES---P VST2SA1015Y---P VST2SC1815Y---P VST2SA1015Y---P VST2SC2412KBQ-A VSIDTC144ES---P VSTDTC363ES---P VRMHNVG--750J-A VRMHNVG--101J-A VRMHNVG--104J-A VRMHNVG--472J-A VRMHNVG--104J-A VRMHNVG--472J-A VRMHNVG--104J-A VRCPTV6--472J-U VRMHNVG--151J-A 47uF 0.47uF 1uF 0.47uF 0.47uF 0.1uF 22PF 220uF 100uF 220uF 10uF 10PF Diode Diode Diode Diode Diode IC IC IC 16V 50V 50V 16V 16V 50V 16V 16V 16V 50V 50V 9-22 Aluminum Elect Aluminum Elect Aluminum Elect High Diel. Chip Capacitor High Diel. Chip Capacitor High Diel. Chip Capacitor Aluminum Elect Aluminum Elect Aluminum Elect Aluminum Elect High Diel. Chip Capacitor 20% ±20% 20% ±20% 20% ±20% 20% ±20% 10% ±10% 5% ±5% 20% ±20% 20% ±20% 20% ±20% 20% ±20% 5% ±5% RLS4148 RLS4148 RLS4148 RLS4148 RLS4148 TA1276AN M52055FP NJM7805FA IC IC IC IC IC IC IC IC IC IC Peaking coil Peaking coil Peaking coil Peaking coil Peaking coil Transistor Transistor IC IC Transistor Transistor Transistor Transistor IC Transistor 75 100 100K 4.7K 100K 4.7K 100K 4.7K 150 VER1.0 NJM7809FA M52472P TC9090AN HEF4052BT NJM2234D 74HC4538D M52055FP 74LS125 TA8772AN UPC1406 100uH 15uH 10uH 100uH 10uH ohm ohm ohm ohm ohm ohm ohm ohm ohm 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/6W 1/8W 5% 5% 5% 5% 5% 5% 5% 5% 5% 2SC1815Y 2SC1815Y DTC144ES DTC144ES 2SA1015Y 2SC1815Y 2SA1015Y 2SC2412KBQ DTC144ES DTC363ES Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Carbon Film Metal Film SME-32DL5(P) ELECTRONIC PARTS LIST R820,847,850 R821,823,855 R822,860,861 R824 R825,826,8A6 R829,831,832 R842,848 R843,886,895 R844,882,884 R845,8C7 R846,849,8C0 R851,852,853 R857,858,8A2 R857,858,8A2 R862,863,864 R865,866,867 R868,Y07 R869,8A0,8F2 R870 R871,874 R872,875,883 R873 R877 R878,8F4,8T1 R879,880,897 R885,887,888 R889,893,894 R890,891,892 R896,859 R898,876 R8A1,8A8,8A9 R8A3,8A5,8J6 R8A4,8E5,8E1 R8A7,8J1,Y08 R8C1 R8C2,8C3,8C4 R8C5,8C6,8H2 R8C8,8E9 R8C9 R8E3 R8E4 R8F3 R8F5 R8F8,8F7,8F6 R8H1,8J3,Y15 R8H3,8H4,8H5 R8H6,8V2 R8H7,8H8,8H9 R8J0 R8J2 R8J2 R8J4 R8J5,8J7 R8J8,8V3,8V4 R8P1 R8P2 R8V1 81 06 30 07 34 09 84 57 57 23 54 30 60 33 33 09 06 72 12 33 82 58 30 81 57 57 73 88 77 33 58 61 34 54 33 33 26 42 07 50 49 33 57 57 51 48 09 76 79 53 09 58 30 64 57 VRMHNVG--101J-A VRMHNVG--223J-A VRMHNVG--222J-A VRCPTV6--222J-U VRMHNVG--473J-A VRMHNVG--104J-A VRMHNVG--561J-A VRMHNVG--102J-A VRMHNVG--102J-A VRMHNVG--821J-A VRMHNVG--221J-A VRMHNVG--222J-A VRMHNVG--562J-A VRMHNVG--750J-A VRMHNVG--750J-A VRMHNVG--104J-A VRMHNVG--223J-A VRMHNVG--183J-A VRMHNVG--331J-A VRMHNVG--103J-A VRMHNVG--303J-A VRMHNVG--391J-A VRMHNVG--222J-A VRMHNVG--101J-A VRMHNVG--102J-A VRMHNVG--102J-A VRMHNVG--152J-A VRMHNVG--822J-A VRMHNVG--332J-A VRMHNVG--103J-A VRMHNVG--472J-A VRMHNVG--683J-A VRMHNVG--473J-A VRMHNVG--221J-A VRMHNVG--103J-A VRMHNVG--103J-A VRMHNVG--123J-A VRMHNVG--752J-A VRMHNVG--182J-A VRMHNVG--122J-A VRMHNVG--153J-A VRMHNVG--103J-A VRMHNVG--102J-A VRMHNVG--102J-A VRMHNVG--000J-A VRMHNVG--100J-A VRMHNVG--104J-A VRMHNVG--680J-A VRMHNVG--820J-A VRMHNVG--333J-A VRMHNVG--104J-A VRMHNVG--472J-A VRNMK01--5R6J-VRNMK01--330J-VRMHNVG--102J-A 100 22K 2.2K 2.2K 47K 100K 560 1K 1K 820 220 2.2K 5.6K 75 75 100K 22K 18K 330 10K 30K 390 2.2K 100 1K 1K 1.5K 8.2K 3.3K 10K 4.7K 68K 47K 220 10K 10K 12K 7.5 1.8K 1.2K 15K 10K 1K 1K 0 10 100K 68 82 33K 100K 4.7K 5.6 33 1K 9-23 ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm ohm VER1.0 1/8W 1/8W 1/8W 1/6W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1W 1W 1/8W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Metal Film Metal Film Metal Film Carbon Film Metal Film Metal Film Metal Film Metal Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Meta l Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Oxide Film Metal Oxide Film Metal Film SME-32DL5(P) ELECTRONIC PARTS LIST RJ1,J2,J3 RJ4 RY04 RY05 RY06,856 RY10,Y11,Y12 RY13 RY14,8E6 S-VIDEO 3 X801 (4.43M) X802 (3.58M) X803 (503K) ZD801,802,803 ZD806,807,808 ZD809,812,813 ZD814,815,816 ZD814A,815A,8 ZD817,818,819 ZD817A,818A,8 ZD820,821,822 ZD820A,821A,8 ZD823,823A "CT" "DB" "FR1" "GND" "PI" "SF" "PS" "TA1" "TA1" "TM" "TM1" "U" 51 51 33 06 85 30 30 60 60 43 41 30 64 64 64 64 64 64 64 64 64 64 67 12 26 50 30 45 42 75 80 53 63 46 39 01 72 01 37 56 31 01 35 73 86 60 49 15 71 VRMHNVG--000J-A VRMHNVG--000J-A VRMHNVG--103J-A VRMHNVG--223J-A VRMHNVG--682J-A VRMHNVG--222J-A VRMHNVG--222J-A VRMHNVG--562J-A QSOCD1557-107-RCRSL1034-1---RCRSL1025-1---ROSCC1026-1---VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U VSZMTZJ5.1B---U QCNWP0092-1042VCNCP030B-EJSTVCNCP0309-EJSTQCNCP1517-1---VCNCP030A-EJSTVCNCP0303-EJSTQCNCP1620-114-VCNCS107ERJJSTVCNCP0306-EJSTVCNCS1078SJJSTVCNCP0302-EJSTXBPSD30P06000-XBPSD30P10000-PISLF0053-1P--PISLF0054-1P--PISLV0129-1P--LANGP0182-1P--A PRDAA0143-1P--D QJAKP1158-1-6-A QJAKP1158-1-6-B QJAKP1159-1-4-B QPWB51087-1G--QPWB51088-1B--ZEPOX-SOMIR200ZFLUXNCF150V--ZSOLDB630-----ZTHNR-4520----- 0 0 10K 22K 6.8K 2.2K 2.2K 5.6K ohm ohm ohm ohm ohm ohm ohm ohm Crystal Crystal Crystal Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Connector Connector Connector Connector Connector Connector Connector Connector SCREW AV SCREW IC804 LANGP0182 LANGP0182 LANGP0182LANGP0182TUNER RADIATOR YUVYUV-AUDIO YUV JACK S-AUDIO,A AV BOARD TRANS 9-24 VER1.0 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 1/8W 5% 5% 5% 5% 5% 5% 5% 5% Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film Metal Film 4.43MHz 3.58MHz 503KHz MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B MTZJ5.1B SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 6. SYNC ON GREEN BOARD PWB C- S01,S02 C- S03 C- S04 C- S05 C- S06 C- S07 C- S08 C- S09,S10,S13 C- S11 C- S12,S16 C- S14 D- S01,S02 S01,S02 ICS01 ICS02 Q- S01 R- S01 R- S02 R- S03,S04 R- S05 R- S06 R- S07 R- S08 R- S09,S10 R- S11 R- S12,S13 R- S14 ZDS01 ZDS02 “MV6 MV6” MV6 SN” “SN SN 71 13 28 08 45 23 53 20 78 77 74 68 89 31 03 01 21 89 54 26 76 72 75 13 50 34 11 47 64 10 15 QPWB51093-1B--VCEACU1EG476M-P VCDCDU1HH121J-P VCDCDU1HH221J-P VCKBDU1HY472K-P VCPELU1HG683J-P VCEACU1HG106M-P VCKBDU1HY103K-P VCEACU1HG475M-P VCEACU1HG105M-P VCDCDU1HH181J-P VCDCDU1HH390J-P VSD1N4148-----U VSIM52346SP---VSI4053BP-----VST2SC1815Y---P VRNMK01--390J-VRMMTV2--271J-U VRCPTV6--332J-U VRCPTV6--153J-U VRCPTV6--393J-U VRCPTV6--223J-U VRCPTV6--104J-U VRCPTV6--563J-U VRCPTV6--152J-U VRCPTV6--102J-U VRCPTV6--392J-U VSZMTZJ12B----U VSZMTZJ5.1B---U LFIX-0002-1F--VCNCP480ARJVEN- SYNCSYNC -ONON - GREEN PWB 47uF 25V 20% 120PF 50V 5% 220PF 50V 5% 4700PF 50V 10% 0.068uF 50V 5% 10uF 50V 20% 0.01uF 50V 10% 4.7uF 50V 20% 1uF 50V 20% 180PF 50V 5% 39PF 50V 5% Diode 1N4148 IC M52346SP IC 4053BP Transistor 2SC1815Y 39 ohm 1W 5% 270 ohm 1/2W 1/2W 5% 3.3K ohm 1/6W 5% 15K ohm 1/6W 5% 39K ohm 1/6W 5% 22K ohm 1/6W 5% 100K ohm 1/6W 5% 56K ohm 1/6W 5% 1.5K ohm 1/6W 5% 1K ohm 1/6W 5% 3.9K ohm 1/6W 5% Zener Diode MTZJ12B Zener Diode MTZJ5.1B Connector Connector 9-25 Aluminum Elect. Temp. Comp. Ceramic Temp. Comp. Ceramic High Diel. Ceramic Polypropylene Film Aluminum Elect. High Diel. Diel. Ceramic Aluminum Elect. Aluminum Elect. Temp. Comp. Ceramic Temp. Comp. Ceramic Metal Oxide Film Metal Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film Carbon Film SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 7. CS PWB CS PWB C383,384 C608 C609 C610 C611 C685 C687 “MV7” D LO LO LO GND1 “LI2” 01 29 12 52 15 02 27 02 40 46 56 66 08 06 47 QPWB51064-1B-3VCENCT1EG475M-P VCMPHF2GG274J-VCMPHF2GG155J-VCMPHF2GG224J-VCPPHF2JG563J-VCPPHF2JG683J-VCPPHF2JG563J-LFIX-0018-1P--QCNCS1633-1---QCNWP0092-1012QCNWP0092-1018QCNWS0092-1019QCNWS0651-1066VCNCP4807RJVEN- CS PWB 4.7uF 25V .27uF 400V 1.5uF 400V .22uF 400V .056uF 630V .068uF 630V .056uF 630V FIX PLATE Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector With Wire Connector 9-26 ±20% ±5% ±5% ±5% ±5% ±5% ±5% Aluminum Elect. Metal Ploy. Film Metal Ploy. Film Metal Ploy. Film Polypropylene Film Polypropylene Film Polypropylene Film SME-32DL5(P) ELECTRONIC PARTS LIST VER1.0 8. RS232 BOARD PWB C1,10 C11,12,13 C14,15 C2 C3,4 C5 C8,9 D1 IC01 IC02 R1,2 R3,4 R5,6,12,13 X1 "RS" 68 45 78 11 77 10 81 52 19 63 15 81 58 68 10 59 76 QPWB51089-1B-- RS232 PWB 47uF 16V 20% VCEACU1CG476M0.1uF 50V 10% VCLBHN1HY104K10% VCLBHN1HY181K- 180PF 50V 1uF 50V 20% VCEACU1HG105M18PF 50V 5% VCICHN1HH180J10% VCLBHN1HY331K- 330PF 50V 1uF 50V 20% VCENCU1HG105MDiode VSDRLS4148---IC MTV212MS64 VSIMTV212MS64IC HIN232CB VSIHIN232CB-T100 ohm VRMHNVG--101J4.7K ohm VRMHNVG--472J33 ohm VRMHNVG--330JRCRSL1179-1--- Crystal 11.0592MHz VCNCP0315-EJST Connec 5PIN QSOCI1517-142- IC01 USE IC SOCKET Aluminum Elect High Diel. Chip Capacitir High Diel. Chip Capacitir Aluminum Elect High Diel. Chip Capacitir High Diel. Chip Capacitir Aluminum Elect Metal Film Metal Film Metal Film 7. SWITCH BOARD PWB J001~007 LD001 LD002 LD003 RGB182 R046 R048 R018,035,068 R052,054,055 R053 R/C SW001~007 “GND” LO “B” “FR” 06 37 22 42 02 36 55 84 89 78 74 57 43 50 08 44 83 48 21 58 79 QPWB51033-1B-2QJUM-1039-1540U VSPHB5-133----VSPHB5-132----VSPHB5-134----QSOCD1549-115-VRMPTV6-1201F-U VRMPTV6-1501F-U VRCPTV6--821J-U VRMPTV6-1001F-U VRMPTV6-8200F-U VSILTM9236E---QSW-A1199-11-1A QCNCP1517-1---QCNWS0092-1019VCNCP0308-EJSTVCNCP030C-EJSTLCHSP0014-1F--GHLDP0068-1FD-XEASD30P10000-HDECP037-1P--- SWITCH PWB jumper POWER LED STAND BY LED POWER SAVING LED 1.2K ohm 1/6W 1% 1.5K ohm 1/6W 1% 820 ohm 1/6W 5% 1K ohm 1/6W 1% 820 ohm 1/6W 1% IC LTM9236E Switch Connector With Wire Connector With Wire Connector Connector CHASSIS HOLDER LED*3 CHASSIS*3 9-27 Metel Film Metel Film Carbon Film Metel Film Metel Film DEFECT BAR CODE LIST VER 1.0 MMM Symptom Table Bar code . . . !. ". "#. #. $. %. %#. &. . . . . . . . . . . . . . . . . . . . . . . . . . sympton Table M100 M200 M300 M400 M500 M526 M600 M700 M800 M826 M900 MA00 MB00 MC00 MD00 ME00 MF00 MG00 MH00 MI00 MJ00 MK00 ML00 MM00 MN00 MO00 MP00 M000 Description 電源開機異常 外觀不良 裝配不良 按鍵異常 聲音異常 重低音不良 調整異常 亮度異常 影像異常 影像跳火 聚焦異常 收斂異常 線性不良 消磁異常 消耗功率不良 水平異常 垂直異常 PUR 異常 彩色異常 色溫不良 背景異常 高壓異常 LED 不良 敲打不良 CRT 不良 遙控異常 OSD 異常 NDF 10-1 English Description No power Poor Cosmetic Poor Assembly Press Button Abnormal Sound Abnormal Poor Doom Function Poor Adjustment Poor Brightness Poor Picture Picture flash Poor focus Poor Convergence Linearity Distortion Poor Degaussing Power Consumption out of spec Poor Horizontal Scan Poor Vertical Scan Poor Purity Color abnormal Poor Color temperature Background abnormal Hold down voltage abnormal LED Defect Shock Noise CRT defect Infrared Receiver abnormal No OSD No Defect Found DEFECT BAR CODE LIST VER 1.0 MMM Root Cause Table Bar code '. '. '. '. '. '. '. '. '. '. ' . '!. '!. '!. '$. '$. '&. '&. '&. ' . '. ' . ' . . . . . . . !. !. . . . . . . Cause Table *OA *OB *OC *IB *2A *2B *2C *2E *2F *2J *3C *4A *4B *4C *7C *7F *9E *9F *9H *OG *1C *2G *3H WC01 WC02 WC03 DR01 DR02 DR03 DR04 WC04 Description 未焊 包焊 流錫短路 斷線 未配 誤配 極性反 裝配不良 插入不良 ㆟為短路 傾斜 機構不良 調整不良 誤判 開路 零件不良 銅箔短路 銅箔開路 其他 焊接不良 破皮 接觸不良 空隙大 客戶誤判 客戶設定錯誤 客戶使用不當 ROM 資料錯誤 ROM 更新版本 ROM 重新燒錄 ROM 設定錯誤 NDF 10-2 English Description Solder-Miss Cold Solderng SolderingShort Soldering Open Missing Part Wrong PART Reversed polarity Assembly Defect Inseration Defect Short by Manual Part Tilt Misformed Installed Worng Incorrect Ruling Open Trace Part Defect Short by copper foil Open by copper foil Other Poor Solder Part Damage Poor Contact Gap too long Customer Incorrect Ruling Customer setting wrong Customer improper use ROM data error ROM update new version ROM rewrite again ROM setting wrong No-Defect-Found PACKING OF THE SET ITME PART NO. 1. SPAKC0623-1R-AO 2. ACCESSORIES 3. SPAKA0579-1F--4. CTV SET 5. SPAKC0623-1R-AO 6. SPAKA0579-1F--- VER1.0 UNIT 1 1 CROP 1 1 CROP REMARKS 11-1 PACKING OF THE SET ITEM PART NO. 1. SPAKC0623-1R-AO 2. JHNDP0020-1---- VER1.0 UNIT 1 4 REMARKS 11-2