1
Download SERVICE MANUAL
Transcript
SERVICE MANUAL MODEL FDL-22 COMMANDER DEST. CHASSIS NO. MODEL MX FDL-22 ∗ Please file according to model size. .... 2.2 COMMANDER DEST. CHASSIS NO. WP LCD COLOR TV SPECIFICATIONS TV standard M Color system NTSC Channel coverage VHF: 2 - 13 UHF: 14 - 69 Antenna VHF/UHF strap antenna Display format Transmission type TN liquid crystal panel Drive format Passive matrix Picture 2.2 inches measured diagonally Output Headphones: minijack Impedance 8 - 45 ohms Power requirements 6 V DC Power consumption Approx. 3.2 W Speaker ∅28 mm (1 1/8 in.) 0.13 W Temperature range 32 °F - 104 °F (0 °C - 40 °C) Dimensions Approx. 81.1 x 153 x 43.4 mm (w/h/d) (3 1/4 × 6 1/8 × 1 3/4 in.) excl. projecting parts and controls Strap length Approx.1,300 mm (51 1/4 in.) Mass Approx. 210 g (7.4 oz), excl. batteries Battery life Approx. 3.5 hours with continuous use Optional accessories AC power adaptor AC-E60HG Size AA (LR6) alkaline battery Design and specifications are subject to change without notice. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY SHADING AND MARK ! ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. –2– TABLE OF CONTENTS Section Title Page 1. GENERAL ....................................................................... 4 Section Cabinet Assy Removal ............................................ A Board Removal ................................................... Service Position ....................................................... 4-1. 4-2. 4-3. 5 5 5 3. CIRCUIT ADJUSTMENTS A Board Adjustment ............................................................ B Board Adjustment ............................................................ 4-4. 6 8 Page 4. DIAGRAMS 2. DISASSEMBLY 2-1. 2-2. 2-3. Title Block Diagram ........................................................ Circuit Boards Location .......................................... Printed Wiring Boards and Schematic Diagrams .... • A Board .................................................................. • B Board .................................................................. • L Board .................................................................. Semiconductors ....................................................... 11 15 15 17 21 25 26 5. EXPLODED VIEW 5-1. Chassis ..................................................................... 27 6. ELECTRICAL PARTS LIST ...................................... 28 –3– –4– b a B c b a A Polarity of the plug Polaridad del enchufe to a wall outlet a una toma mural VOL 2 VHF/UHF/ OFF CH +/– BRT 700mA DC IN 6V AA (LR6) × 4 Serial No. Model No. FDL-22 The model and serial numbers are located at the rear. Record the serial number in the space provided below. Refer to these numbers whenever you call upon your Sony dealer regarding this product. Owner’s Record This symbol is intended to alert the user to the presence of important operating and maintenance (servicing) instructions in the literature accompanying the appliance. This symbol is intended to alert the user to the presence of uninsulated “dangerous voltage” within the product’s enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons. To prevent fire or shock hazard, do not expose the unit to rain or moisture. WARNING English Set the VHF/UHF/OFF switch to VHF or UHF whichever band you want to watch. Press the CH +/– button to select a channel. Adjust the volume with the VOL dial. Adjust the brightness with the BRT dial. See fig. B–b. How to use the stand Listening with headphones: Connect headphones (not supplied) to the 2 (headphones) jack. To improve the broadcast reception: Extend the strap antenna and move the unit in every direction. You can also adjust the length of the strap. (See fig. B–a). To switch off the TV: Set the VHF/ UHF/OFF switch to OFF. 4 3 2 1 Operation (see fig. B) Note Use only the recommended AC power adaptor. (For the polarity of the plug, see fig. A–c). See fig. A–b. House Current Note When the picture becomes dimmer or the tuning does not lock into a channel, replace all the batteries with new ones. Battery Life: With continuous use, Sony LR6 alkaline batteries will last about 3.5 hours. See fig. A–a. Alkaline Batteries If you have any questions or problems concerning your unit, please consult your nearest Sony service facility. No picture • Weak batteries. No sound from the speaker • Volume is turned down completely. • Weak batteries. Dotted lines or stripes • Often caused by interference from other electric appliances. • Adjust the strap antenna. Herringbone pattern, double images, stripes, too indistinct, etc. • Improper tuning or antenna setting. The unit does not operate. • The AC power adaptor is disconnected. •Incorrect battery polarity. • Weak batteries. Troubleshooting • Operate the unit only on 6 V DC. For AC operation, use the recommended Sony AC power adaptor. Do not use any other type of AC power adaptors for this unit. • Do not open the unit. Refer servicing to qualified personnel only. • Do not place the unit in a hot or humid place or in a place subject to excessive dust or vibration. • Avoid rough handling. • Clean the unit with a soft cloth slightly dampened with a mild detergent solution. Never use strong solvents, such as thinner or benzine, as they may damage the finish. Precautions The operating instructions mentioned here are partial abstracts from the Operating Instruction Manual. The page numbers of the Operating Instruction Manual remein as in the manual. Power Sources GENERAL SECTION1 SECTION 2 DISASSEMBLY 2-1. CABINET ASSY REMOVAL 2-2. A BOARD REMOVAL 1 Battery cover 2 Three screws (+P2x10) 2 A board 3 Rear cabinet assy 1 One screw (+B2) Channel button *When attaching, be sure to confirm that the correct side is facing up. Power switch button 4 Front cabinet assy 2-3. SERVICE POSITION Service cord 1-900-211-84 CN502 B board AC power adaptor CN201 A board cord Antenna –5– –6– Measure *JL with a *digital voltmeter and adjust *RV for the *Voltage. +4.5 ADJUSTMENT A BOARD ADJUSTMENT ADJUSTMENT ITEM AND PROCEDURE *Digital Voltmeter EQUIPMENT AND SIGNAL *JL61 MEASUREMENT POSITION CIRCUIT ADJUSTMENTS SECTION 3 *RV601 ADJUSTMENT LOCATION *4.55 ± 0.05 V DC TU101 RV201 RV601 RV001 RV003 – A BOARD – (COMPONENT SIDE) ILLUSTRATION AND SHAPE AND NUMBER –7– 3. Power switch in I. 4. Recieve 21CH then adjust channel No. display position by *RV to be in the *Specification. 5. Recieve 68CH then adjust channel No. display position by *RV to be in the *specification. 6. Repeat the procedures 9 and 10 in a few times to be in the specification for both of 21CH and 68CH. 7. Recieve 40CH then check and confirm position of the display bar in the specification. 8. Release the variable resister and resister out and open the short circuitry between JL04 and JL60. 2. Short circuitry between JL04 and JL60 (GND). 1. Insert variable resister (47 kΩ) and resister (15 kΩ) between JL06 and JL61. (Fig 1.) CHANNEL DISPLAY POSITION ADJUSTMENT ADJUSTMENT ITEM AND PROCEDURE EQUIPMENT AND SIGNAL MEASUREMENT POSITION *RV003 S601 *RV001 ADJUSTMENT LOCATION 21 Fig 2. Channel No. Display bar 47kΩ JL61(4.5V) *Channel No. and display bar are to be in line. *Channel No. and display bar are to be in line. * 15kΩ Fig 1. JL06(CS) ILLUSTRATION AND SHAPE AND NUMBER –8– 2. Check and confirm waveform at *JL30 by *oscilloscope to be in the *specification. 3. Connect oscilloscope CH1 to *JL34, then vary *RV and confirm picture contrast of screen changes relevantly. 4. Connect oscilloscope CH2 to *JL40, then adjust amplitude of A by *RV to be in the *specification. 5. Connect oscilloscpe CH2 to *JL40 and confirm leading edges of C and D to be in the area of ˜ . 1. Receive a *signal GRAY SCALE SIGNAL ADJUSTMENT B BOARD ADJUSTMENT ADJUSTMENT ITEM AND PROCEDURE * 10-gradation gray scale * Oscilloscope EQUIPMENT AND SIGNAL *JL40 (AUTO C) *JL40 (AUTO C) *JL34(G) *JL30 (VIDEO) MEASUREMENT POSITION *RV402 *RV402 ADJUSTMENT LOCATION JL40 (CH2) 0 IRE JL34 (CH1) C * A=1.8±0.2V D 100 IRE Picture contrast is varies. *0.62 ± 0.05Vp-p (0 IRE - 100 IRE) RV402 RV301 – B BOARD – (COMPONENT SIDE) ILLUSTRATION AND SHAPE AND NUMBER –9– 1. Receive a *signal. 2. Connect a *oscilloscope to *JL32. 3. Adjust waveform by *RV to be *Fig 3 or *Fig 4. PHASE ADJUSTMENT ADJUSTMENT ITEM AND PROCEDURE * Color-bar * Oscilloscope EQUIPMENT AND SIGNAL *JL32 (B) MEASUREMENT POSITION *RV301 ADJUSTMENT LOCATION Fig 4. Fig 3. Small wize line ILLUSTRATION AND SHAPE AND NUMBER RF IN TU101 TUNER S601 (2/1) UA RV003 UP RV001 BUFF Q001 SW Q006 AMP Q002 IF AMP Q201 – 11 – A(TUNER,VIF/SIF DET, TUNING) TV MB UB VB BS AGC IF 4-1. BLOCK DIAGRAM SECTION 4 DIAGRAMS 22 18 26 27 28 UA UP BT U/V BS FILTER SWF201 POSITION ADJUST BAR DISPLAY BT G E N. BAND SELECT BS COMPOSITION INITIAL SET AUTO RETURN INPUT CONTROL TUNING CONTROL 3 BA R OUT PUT COMPARATOR SIGNAL DEFECT DEFEAT OUT PUT IC001 TUNER CONTROL CHARGE/ DISCHARGE CIRCUIT HP U V CS SUD AFC H SYNC FH DEF 30 31 10 6 4 5 1 14 S601 (2/2) INV/SW Q003,004 S001 INV Q205 BATTERY S002 Q007 AFC SW FH SW Q005 RV201 F601 AFT 21 17 23 CF202 4 6 7 3 AFT COIL AFT SYNC AGC DL AGC OUT IF IF E-VDL FM DET DC IN J701 BATT 4 UNREG 3 3 4 UNREG 1 1 CN601 PROT SW Q610 PORT SW Q601-603 IC201 VIF/SIF DET AFT SYNC SEP LIM FM DET RV601 16 15 14 AGC IF IF ANP DRIVE Q702 13 OUT T601 22 10 18 DET SIF AUDIO DRIVE Q701 – 12 – CN701 4 8 9 19 20 REF COIL SYNC SEP VIDEO AMP LIMITER BUFF VIDEO DET REF COIL 1 5 4 2 3 T701 +4.5V +30V BUFF Q202 VIDEO AUDIO 6 RV501 + 2 3 X301 4.43MHz RV301 23 21 19 2 1 VCXO OUT VCXO IN TINT CONT SYNC SEP VIDEO IN IC501 HP AMP + IC301 Y/C/J B(HP AMP,MONITOR CONTROL, CHROMA) CN502 BLACK LIGHT UNREG 6 8 IND 8 7 H SYNC 9 5 H.P VHF L(DC IN, B/L INV) 3 7 6 1 CF201 CF203 LLD 3 2 CN201 HD IN B OUT G OUT R OUT CONTRAST VCC 12 11 10 9 5 6 INV Q302 IND SW Q408 SYNC SEP Q303 – 13 – SPEAKER PHONES J501 27 29 28 23 38 40 35 34 37 B IN G IN R IN AUTO CB R INB H IN V IN HSO BUFF Q402 10 13 TPR1 DB 12 TPR1B IC401 MONITER CONTROL 2 D1 9 8 XTI TGL VL XTO 20 30 21 RV401 BUFF Q401 SW Q406 VM BUFF Q407 BESTB 7 6 D3 D4 5 4 D2 CLA 3 1 CP CL2 CLB RV402 X401 4.5MHz +30V 22 38 15 31 VS 2 32 16 34 33 18 17 VS 2 VDB VDB VDR VDG VDR VDG 3 4 VM VSS 39 23 6 2 13 29 9 25 VM VM TPR1 TPR2 RES RES D1 D1 D4 D4 D3 10 26 11 27 D3 20 36 12 28 D2 D2 CLA CLA 21 37 24 40 CP CP CL2 CL2 CLB CLB LCD MONITOR – 14 – A L METAL FILM : panel designation and adjustment for repair. wise noted. : ALR • • : signal path. : B+line. • Circled numbers are waveform references. v * : Measurement impossibillity. • All voltages are in V. – 15 – HIGH RIPPLE HIGH TEMPERATURE Note: The components identified by shading and mark ! are critical for safety. Replace only with part number specified. : ALT • Voltages are dc with respect to ground unless otherwise noted. • Voltage variations may be noted due to normal production tolerances. • Readings are taken with a 10M digital multimeter . BIPOLAR METALIZED POLYPROPYLENE : ALB : MPP POLYPROPYLENE MYLAR STYROL METALIZED POLYESTER : PT : MPS : PP : PS • Readings are taken with a color-bar signal input. gram, see the another list • As to the voltage volue shown by the semiconductors on the Shematic Dia- TANTALUM CAPACITOR : TA : internal component. • All variable and adjustable resistors have characteristic curve B, unless other- • • NONFLAMMABLE CEMENT ADJUSTMENT RESISTOR : : LF-8L MICRO INDUCTOR COIL Rating electrical power : 1/ 4 W (CHIP : 1/10W) : RB NONFLAMMABLE METAL OXIDE Pitch : 5mm as follows. : RS NONFLAMMABLE WIREWOUND : FUSE NONFLAMMABLE FUSIBLE : RW : FPRD NONFLAMMABLE CARBON • Indication of resistance, which dose not have one for rating electrical power, is k =1000 , M =1000k • All resistors are in ohms. SOLID • All electrolytics are in 50V unless otherwise specified. : RC : RN RESISTOR • All capacitors are in µF unless otherwise noted. pF : µµF 50WV or less are not indicated except for electrolytics and tantalums. Reference information Note: 4-3. PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS B Diode Diode Diode 7 8 9 Transistor Transistor Discrete semiconductot @£ – Emitter (NC) Cathode Cathode Anode Anode Cathode Cathode Emitter Collector Base Source Drain Gate Source Gate Source Gate Cathode Anode Anode C1(B2) C2 C2 C1 (B2) E2 E1 B1 C1 (B2) B1 E1 E2 C2 E2 B1 E1 E1 B1 C2 C1 B2 E2 E1 B1 C2 C1 B2 E2 E1 B1 C2 C1 B2 E2 E2 B2 C1 C2 B1 E1 Drain Drain Anode Anode Cathode Cathode Common Cathode Common Anode Common Anode Common Anode Common Anode Common Anode Anode (NC) Cathode Anode Cathode Emitter Collector Base Base Cathode G B1 B1 B1 B1 B1 B1 S D (Chip semiconductors that are not actually used are included.) Transistor @™ Transistor Transistor Transistor Transistor Transistor Transistor (FET) Transistor (FET) Transistor (FET) Diode Diode @¡ @º !ª !• !¶ !§ !∞ !¢ !£ !™ !¡ Diode Diode 0 Diode 4 6 Diode 3 5 Transistor Diode 2 Transistor Terminal name Collector C1 C1 E1(B2) E2 E1(B2) C1 C1(B2) E1 E1 C1 E1 C1 S D G S E2 C2 C2 C2 C2 E2 E2 C2 C2 E2 E2 C2 D G Circuit S D Ver.1.5 B2 B2 B2 G 1 – 16 – 3.4Vp-p (H) 2 • A BOARD WAVEFORMS 3.7Vp-p (H) 3 0.9Vp-p (H) J I H G F E D C B DRY BATTERY 4PCS.6V R020 470k :CHIP S601 2-3 R019 270k :CHIP UA RV004 100k VA :CHIP RV003 100k :CHIP C003 560p 1 CH:CHIP 3 1.2 5 3 4 1 2 0 F601 1A 125V 1.1 R608 56k :CHIP R601 56k :CHIP 30V UNREG C012 0.47 25V F:CHIP 0.8 R005 150k :CHIP VHP UP – 17 – Q601 2SD601A-R CONTROLLER 0.6 Q006 XN4215 VH/VL SELECT 0 1.4 5 3 33k :RN-CP 1.4 R009 R022 R024 47k 47k :CHIP :CHIP 30V Q002 XN4601 DC AMP R003 56k :CHIP R002 82k :CHIP C001 4.7 16V :5L R111 10 :CHIP C002 22 6.3V :5L R001 120k :CHIP 0.7 C106 0.01 B:CHIP VCC R606 0 :CHIP C605 47p CH:CHIP 5 4 8 9 T601 R616 1.2k :CHIP 2 3 7 6 1 1 C610 470p CH:CHIP R611 1.2k :CHIP C611 10 :5L C619 0.0047 B:CHIP D603 RB160L R610 100 :CHIP 4.5V R018 100k :CHIP C004 R010 47 4.7 6.3V :CHIP :5L C006 0.47 R015 25V 10k F:CHIP:CHIP D602 MA199 R017 18k :CHIP 1 R029 470 :CHIP 30V C016 0.47 25V F:CHIP * 4.5 IF S002 UP R014 39k :CHIP C005 0.01 B:CHIP R021 100k :CHIP S001 2 R013 56k :CHIP 0 C007 0.001 B:CHIP Q603 2SD1119-Q 0.1 4.1 0.2 2 R016 39k :CHIP DOWN 3.9 3.9 Q003 UN2210-TX MUTE 2.6 Q007 UN211D-TX AFT-SW 4.5V 7 C014 0.47 25V F:CHIP C008 0.47 25V F:CHIP 4.4 REG OUT R602 R603 C604 47k 22 0.0047 :CHIP :CHIP B:CHIP R604 330 :CHIP C603 0.1 B:CHIP 0.8 Q602 2SD601A-R REG OUT R605 100 :CHIP D605 MA111-TX R011 10k :CHIP 4.4 D002 MA157-TX R031 220k :CHIP Q004 UN2110-TX MUTE C109 0.01 B:CHIP C110 0.01 B:CHIP 2.6 UH 3.0 2.5 SUD 2.1 4.0 VLP AFC IC001 2.1 0.4 AN5707NFAP CON HSYNC ELECTRONIC TUNING 3.1 0.2 UA H.P 0 2 VHA M.M 2.2 0 FH VLA 1.9 2.2 BRT 31.3 4 1 31.3 2 R008 270k :RN-CP 6.3 6 47k :CHIP 31.3 R004 Q001 2SB709A-R VOLTAGE SETTING VP 19.8 6 UP RV002 47k :CHIP 2 D001 MA152WK-TX RV001 47k :CHIP C011 10 6.3V :5L R012 330k :CHIP ANT AGC UB TV BS VB MB IF TU101 TEPA5 2 G 8 7 6 5 4 3 1 1 Printed symbol 24 23 22 21 20 19 18 17 6 0.3 3 L601 47µH :FR-CP R612 220 :CHIP 560 :CHIP 1 R613 220 :CHIP 2 RV601 C616 0.01 B:CHIP C617 100 6.3V :5L C227 0.01 B:CHIP 1 2 3 4 C228 0.01 B:CHIP IF IF 10 R217 C211 390 0.01 G G O :CHIP B:CHIP Q610 2SB709A-R CONTROLLER D601 R220 47 :CHIP O SWF201 F57DM R215 22 :CHIP B:CHIP I C209 4.1 0.01 L205 0.82µH :CHIP 0.6 MA8043-M 31.5 C210 R219 390 0.01 B:CHIP :CHIP 31.5 9 Q201 2SC3837KT146Q RF AMP R216 R218 1.2k 68 :CHIP :CHIP R615 10k :CHIP 8 1.1 4 6 R243 22k :CHIP 24 AFT 1 L208 10µH :FR-CP C223 0.47 25V :TA-CP R225 R226 3.9k 3.3k :CHIP :CHIP 23 22 C208 2p CK:CHIP C207 47p CH:CHIP 1 2 3 1 3 21 IF 4 R230 10 :CHIP 4.5V C224 0.01 B:CHIP R223 1k :CHIP 2 C234 0.01 B:CHIP 13 LLD 20 5 19 R209 1.8k :CHIP 3 7 R231 22 :CHIP R229 8.2k :CHIP RV201 1k :CHIP R224 1.5k :CHIP C216 0.01 B:CHIP IF 6 C215 47 6.3V :5L 18 17 16 15 R212 330 :CHIP 9 10 – 18 – 8 14 R206 680 :CHIP 14 C205 4.7 6.3V :TA-CP 2.6 0 3.5 30V 1 2 3 4 5 6 7 8 9 10 11 12 B-¥SSYV832<MX/WP>-A.. Q203 UN2210 MUTE C213 0.01 F:CHIP 12 C220 2.2 6.3V :TA-CP R228 10k :CHIP R213 10k :CHIP 13 C218 0.01 B:CHIP 11 C204 0.01 B:CHIP R208 680 :CHIP R240 10k :CHIP 2.0 R032 2.2k :CHIP R201 680 :CHIP C015 100p CH:CHIP Q202 2SB709A-R BUFFER C010 0.01 B:CHIP L201 15µH :CHIP R241 R202 CF201 220 TPS6.0MB T202 180k 38.9MHZ :CHIP :CHIP R242 470 :CHIP UNREG UNREG GND TO L BOARD CN701 UNREG BATT GND CN601 4P 4.5V C235 0.001 B:CHIP T201 38.9MHZ C219 0.47 C222 25V 10 :TA-CP 6.3V :TA-CP R222 8.2k :CHIP 12 A(ELECTRONIC TUNER,VIF,SIF) 11 6 5 IC201 M51348AFP VIF/SIF NC 16 4.3 CHCAL 15 0 DEF 14 4.4 STOP 13 MANU 12 2.2 CHA 11 0.7 CS 10 NC 9 25 NC 26 BT 0.9 27 U/V 3.9 28 BS 0 29 GND 30 V OUT 0 31 U OUT 0 32 NC 0 C601 100 10V :5L 2.0 4 D604 MA8360-TX 3 C612 0.01 B:CHIP 1.9 3.4 Device 2 R614 33k :CHIP AUDIO OUT Terminal name of semiconductors in silk screen printed circuit ( * ) 1 2.1 4 3.3 REF COIL IF IN AUDIO 3.5 VIDEO A C614 0.01 B:CHIP CF202 CDSH6.0MC30K 4-2. CIRCUIT BOARDS LOCATION C615 0.01 B:CHIP 1.6 VIDEO DET OUT IF IN C206 27p CH:CHIP E-VDL DC F/B 1 2 3 3.3 IF AGC AGC FILTER OUT ADJ 1.7 3.3 AGC SYNC OUT FILTER IN 0.4 1.8 RF AGC SYNC SEP 3.4 OUT 3.3 RF AGC AFT COIL DELAY 3.4 4.2 REF COIL VCC (VIF) 1.9 C225 0.01 B:CHIP C226 0.01 B:CHIP 1.8 GND (SIF) R205 R210 33k :CHIP 100k :CHIP C203 0.1 25V F:CHIP AFT OUT GND (VIF) 2.4 4.3 LIMITER VCC OUT (SIF) 1.5 1.6 SIF IN FM DETIN C212 0.01 B:CHIP CF203 SFSH6.0MCB SIF SIF R221 1k :CHIP C613 33 10V D.GND VHF H.P 4.5V AUDIO TO B BOARD UNREG H.SYNC CN502 IND VIDEO A.GND 30V UNREG GND CN201 12P 15 IF AGC DET SUD 6 FH 1 H.syn 4 M.M. 2 H.P. 3 AFC 5 29 GND 16 9 NC NC INITIAL RESET AUTO RETURN PLUSE WIDTH SET COMPARATOR 26 25 NC 32 NC 26 BT 1 AGC FILTER I 2 AGC FILTER II 3 RF AGC OUT B 12 MANU INPUT CONTROL UP DN TUNING CONTROL DEFEAT OUT – 19 – 10 C.S. CHARGE/ DISCHAGE STOP DEF CHCAL BRT 14 15 17 BT GENERATOR SIGNAL DET STOP 13 A BOARD : IC001 AN5707NFAP IF AGC ADJ 24 SYNC OUT 23 SYNC SEP IN 22 SYNC SEP 6 IF IN 4 RF AGC DELAY AGC 1st Amp 7 IF IN 8 GND (VIF) 9 Vcc (SIF) 10 SIF IN 11 DC F/B 5 Vcc (VIF) VIDEO DET 2nd Amp VIDEO AMP LIMITER 12 GND (SIF) AFT COIL 21 AFT FM DET BUFFER REF COIL 20 REF COIL 19 VIDEO OUT 18 AFT OUT 17 LIMITER OUT 16 FM DET IN 15 E-VDL 14 AUDIO OUT 13 A BOARD : IC201 M51348AFP 11 CHA U/V 27 23 VHA 24 VLA ADJUST POSITION BAR DISPLAY BAR OUTPUT BS ADD BAND SW L/H 7 Vcc 5V 8 22 UA 21 CON 19 VHP 20 VLP 18 UP 31 U OUT 30 V OUT 28 BS G-3 G-2 H-6 I-6 G-2 H-7 G-3 B-5 H-4 C-6 F-5 D-6 C-6 RV001 RV002 RV003 RV004 RV201 RV601 B-6 B-6 B-6 B-6 C-4 C-5 VARIABLE RESISTOR Q001 Q002 Q003 Q004 Q006 Q007 Q201 Q202 Q203 Q601 Q602 Q603 Q610 B-7 G-4 H-6 I-7 G-6 C-7 G-6 G-6 G-6 1 !™ 1 1 !¡ 1 1 2 1 2 1 2 2 6 4 3 6 3 3 3 * TRANSISTOR * IC001 IC201 IC D001 D002 D601 D602 D603 D604 D605 DIODE A BOARD I H G F E D C B A 1 < Conductor Side > < Component Side > 2 ELECTRNIC TUNING, VIF, SIF – A BOARD – A 3 4 – 20 – 5 6 7 J I H G F E D C B TO A BOARD CN201 D.GND VHF H.P. 4.5V AUDIO UNREG H.SYNC IND VIDEO A.GND 30V UNREG GND CN502 12P 1 2 3 4 5 6 7 8 9 10 11 12 AUDIO C501 0.01 B:CHIP RV501 3 10k 1 2 R503 4.7 1/8W :CHIP R509 120k :CHIP R502 4.7 1/8W :CHIP V+ OUTPAT GND +IN -IN GND NC NC UNREG 4 VCXO R304 15k :CHIP R303 470 :CHIP R302 56k :CHIP R301 33k :CHIP R325 8.2k :CHIP D501 MA157-TX C306 0.1 25V B:CHIP R506 390 :CHIP R505 470 :CHIP R504 470 :CHIP RV301 22k :CHIP C507 0.22 25V F:CHIP R501 4.7 :CHIP AUDIO C505 100 6.3V :5L AUDIO L501 0.47µH 10% :CHIP 2 3 R323 2.2M :CHIP R324 10k :CHIP 4.3 4.0 C308 680p CH:CHIP 1 4 0.5 C312 Q303 2SB709A-R 0.1 25V BUFFER F:CHIP R314 100k :CHIP C310 0.01 B:CHIP R310 68k :CHIP 6 R G B 1 10k :CHIP 3 R447 50k 2RV40112.2 8 7 R316 330k :CHIP R322 68k :RN-CP R327 0 :CHIP MA3J142E0LSO D401 3 0.6 Q302 UN2210 BUFFER 3.7 R317 4.7k :CHIP C434 0.01 B:CHIP R416 10 :CHIP 2 1 R407 2.2k :RN-CP 4.5 R418 1.5k :CHIP 4.5V C416 0.01 B:CHIP 4.5V B C425 4.7 10V :TA-CP C424 0.001 B:CHIP C423 0.001 B:CHIP C422 0.001 B:CHIP C421 22p CH:CHIP 9 11 10 9 VSSC 1 7 6 R410 39k :CHIP 5 C410 0.1 25V B:CHIP 4 3 1.7 2 0 Q406 XP4601 BRIGHTNESS CONTROL R409 68k :CHIP 10 0 1 IC401 A71-2980 LCD INTERFACE RB402 RB403 RB404 2.2kx2 2.2kx2 2.2kx2 1/16W 1/16W 1/16W :CHIP :CHIP :CHIP C427 0.01 B:CHIP R422 10k :CHIP RV402 22k :CHIP C428 0.01 B:CHIP R423 6.8k :CHIP R428 27k :CHIP 23 24 25 26 27 28 29 30 31 32 33 G 1.8 XTO XTI VDDC 8 C409 0.1 25V B:CHIP RB401 TPR1B 2.2kx2 3.7 1/16W TPR1 :CHIP 0 3.7 CV3 1.7 CV2 1.7 CV1 1.7 PLLO 1.8 PLLO2 1.9 C408 0.01 B:CHIP R 12 13 14 15 16 17 18 19 20 21 22 C430 0.01 B:CHIP R431 100 :CHIP R430 100 :CHIP R429 100 :CHIP R419 C420 10k :CHIP 12p R420 CH:CHIP 1k :CHIP 1.9 X401 4.5MHz C419 0.1 25V B:CHIP C418 0.01 B:CHIP C415 100 6.3V :5L C407 47 6.3V :5L C406 22 6.3V :5L C405 22 6.3V :5L Q402 2SD1819A-R BUFFER 8 R432 C403 100 22 :CHIP 4V :TA-CP R408 2.4k :RN-CP R406 270 :CHIP R404 27k :CHIP R405 3.0 68k :CHIP 3.6 7 D402 MA111-TX C402 4.7 35V :5L 4.5V R403 47 :CHIP C401 0.01 B:CHIP R318 R315 33k 22k :RN-CP :CHIP 9 10 11 12 D301 MA111-TX 7 8 3.0 6 5 5 2.5 R308 15k :CHIP SPEAKER Q401 2SD601A-S BRIGHTESS JW501 12.5MM SP R402 82k :CHIP R307 56k :CHIP R401 120k :CHIP HEADPHONE 2.1 2.4 24 23 22 21 20 19 18 17 16 15 14 13 R312 560 :CHIP C314 4.7 6.3V :TA-CP – 21 – C313 0.001 B:CHIP R320 1.5k :CHIP R311 150k :CHIP C307 4.7 6.3V :TA-CP VIDEO 3 IC301 M52042FP CHROMA 2 4.3 X301 3.58MHz C302 22PF CH:CHIP R309 10 :CHIP C301 100 6.3V :5L 30V C504 IC501 10 6.3V NJM2070M-TE2 :TA-CP AUDIO AMP C502 100 10V :5L UNREG R510 10k :CHIP C506 0.1 25V F:CHIP VIDEO D502 MA157-TX 6 31.8 J501 C309 0.1 25V B:CHIP D405 MA111-TX SP.GND D406 MA8240-TX 5 1.7 180pC303 CH:CHIP C304 3.40.01MF B:CHIP R305 15k :CHIP 11.7 A 2.7 2.9 0.7 3.7 R313 470k :CHIP 2.9 C305 470p CH:CHIP 2.5 2.5 C404 0.01 B:CHIP 4 3.7 0 0.9 VIDEO VCC IN SYNC VCXO OUT SEP IN VCXO ACC FILTER MONITER VCXO SYNC OUT 3.5 IN COLOR HD IN CONT TINT CLUMP CONT CHROMA KILLER FILTER TRAP APC Y OUT FILTER 2.7 CONTRAST SW KILLER R OUT OUT PIX G OUT CONT GND B OUT VDDB AUTOCB 3 VDDA DB AUTOC 11.6 2 BT 1 R424 2.7k :CHIP 4 VSSB SGD1B 3.7 HSO 0.5 VS2 0 HIN 0.5 VIN 0.5 INB B2 0.4R2 0 G2 MUTEB 3.7 R421 10k :CHIP R417 4.7k :CHIP 44 43 42 41 40 39 38 37 36 35 34 R436 10k :CHIP 0 UN5210 BUFFER 3.7 Q408 R427 1k :CHIP R415 22k :CHIP B C429 0.01 B:CHIP 13 – 22 – B-¥SSYV832<MX/WP>-B.. AUDIO AMP, CHROMA LCD INTERFACE :CHIP 1.7 R414 22k Q407 XP4601 TPR AMP C414 100p CH:CHIP 0 12 C413 R412 100p 22k CH:CHIP :CHIP R413 22k :CHIP 1.7 3.7 D404 MA111-TX Q403 DTC114TK D403 MA111-TX C412 0.47 25V F:CHIP R411 1M :CHIP C411 0.47 25V F:CHIP 11 RB405 2.2kx2 1/16W :CHIP 12.3 1.9 BESTB 3.1 D1 1.2 D4 1.2 D3 1.2 D2 1.2 CLA 0.6 CLB 0.6 CL2 0 CP 0.9 5 3.3 BIN 1.2 RIN 1.2 GIN 1.2 TGLVL 0.8 RB 0.1 0 3 6 PALB 2 7 VSSA 1 8 N.C. TPR2 VSS VM VDD TPR1 N.C. N.C. D1 D4 D3 D2 RESTB VS1 VS2 VDB VDG VDR VD1 CLA CLB CL2 VM CP D1 D4 D3 D2 RESTB VS1 VS2 VDB VDG VDR VD1 CLA CLB CL2 VM CP N.C. N.C. N.C. 14 TO LCD PANEL 15 5 1 4.2Vp-p (H) 4.8Vp-p (4.5MHz) 6 2 • B BOARD WAVEFORMS GND 4 0.7Vp-p (H) 0.4Vp-p (3.58MHz) 7 3 100kΩ – 23 – 0.9Vp-p (H) 0.9Vp-p (H) 5 POWER GND 6 OUTPUT + - -INPUT 3 50kΩ 7 V+ BIAS +INPUT 2 300Ω 8 NC NC 1 B BOARD : IC501 NJM2070M 8 4 0.9Vp-p (H) 0.8Vp-p (H) B-3 C-2 C-5 B-3 D-2 G-2 B-1 H-2 E-2 E-3 C-5 C-5 1 2 1 2 1 !£ !£ 2 3 7 3 3 3 3 3 5 5 * G-3 C-3 E-3 D-2 G-2 A-2 A-2 B-2 RV301 RV401 RV402 RV501 B-3 D-3 C-3 D-4 VARIABLE RESISTOR Q302 Q303 Q401 Q402 Q403 Q406 Q407 Q408 TRANSISTOR * IC301 IC401 IC501 IC D301 D401 D402 D403 D404 D405 D406 D501 D502 DIODE B BOARD H G F E D C B A 1 2 AUDIO AMP, CHROMA, LCD INTERFACE – B BOARD – B 3 – 24 – 4 < Conductor Side > < Component Side > 5 6 C B A 1 3 0 Q702 2SC1318R 4.0 0 Q701 2SC1318R R701 330 1/4W 4 C702 0.15 :PPS 4.0 5 1 4 3 2 T701 5 6 7 8 FR701 15p 2kV 9 C703 – 25 – B-¥SS5113<U..>-L.. L(PC IN,BACK LIGHT) D704 1SR139 D703 D701 1SS133T-77 1SR139 R702 D702 100 1SS133T-77 1/4W C701 330 10V L701 100µH [ DC IN, BACK LIGHT ] J701 – L BOARD – L DC IN 6V TO A BOARD CN601 CN701 4P 1 UNREG UNREG GND 2 3 UNREG BATT GND 4 2 6 TOP VIEW TOP VIEW TOP VIEW 24 pin SOP 3 3 2 2 XN4215 B 1 1 4 E 4 5 5 C 8 pin SOP TOP VIEW UN2110 UN211D UN2210 UN5210 2SB709A 2SC3837KQ 2SD601A 1 NJM2070M 1 M51348AFP M52045FP 32 pin QFP 1 AN5707NFAP 44 pin QFP 1 A71-2980 6 6 4-4. SEMICONDUCTORS 2 2 1 2 2 3 1 1 3 4 E 1 B 6 6 5 5 2 2 1 1 3 3 5 5 6 6 MA152WK MA3J142E0LS0 1SS184 2 E 2SD1819A C 2SD1119-Q B 4 E C B 2SC1318R 1 XP4601 3 3 XN4601 3 C 4 4 – 26– 2 1 3 2 ANODE ANODE CATHODE 1SR139-400 1SS133T CATHODE 2 CATHODE 3 3 3 RB160L-40TE25 ANODE 1 1 1 1 MA111 MA8240 MA8360 1 MA8043 2 MA199 2 2 MA157 1SS226 SECTION 5 EXPLODED VIEW NOTE: • The construction parts of an assembled part are indicated with a collation number in the remark column. • Items with no part number and no description are not stocked because they are seldom required for routine service. The components identified by shading and mark ! are critical for safety. Replace only with part number specified. • Items marked " * " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. 5-1. CHASSIS : 7-685-106-19 +P2 X10 1 15 2 4 14 16 17 9 8 21 3 5 6 7 10 20 11 12 18 19 REF. NO. PART NO. ------------ ------------1 4-048-324-01 2 X-4032-638-4 3 4-048-321-01 4 4-048-322-01 5 * 4-048-327-01 6 7 8 9 10 1-810-873-12 * A-1135-818-A 1-504-847-11 4-048-551-01 * 4-048-325-01 11 1-517-425-13 DESCRIPTION ------------------FILTER CABINET ASSY, FRONT SWITCH, POWER BUTTON, CHANNEL SHIELD, PANEL 13 REMARK ------------- REF. NO. PART NO. ------------ ------------12 * 4-048-317-01 13 * A-1394-649-A 14 * A-1297-491-A 15 ! 1-693-219-11 MODULE, INDICATOR B BOARD, COMPLETE SPEAKER (2.8CM) SPACER, SPEAKER ILLUMINATOR LIGHT, BACK – 27 – DESCRIPTION ------------------REFLECTOR L BOARD, COMPLETE A BOARD, COMPLETE TUNER UNIT (TEPA5) 16 17 18 19 20 4-908-792-51 X-4032-639-4 4-048-323-01 1-501-767-11 4-048-320-01 SCREW (B2) CABINET ASSY, REAR COVER, ANTENNA ANTENNA, STRAP COVER, BATTERY 21 4-048-468-01 SPRING (B), BATTERY REMARK ------------- 21 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. SECTION 6 ELECTRICAL PARTS LIST B PART NO. ------------- DESCRIPTION ------------------- The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REMARK ------------- REF. NO. ------------ PART NO. ------------- • Items marked " * " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • All variable and adjustable resistors have characteristic curve B, unless otherwise noted. RESISTORS • All resistors are in ohms • F : nonflammable REF. NO. ------------ --------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------- REF. NO. NOTE: ------------ PART NO. DESCRIPTION ------------------------------* A-1135-818-A B BOARD, COMPLETE ********************* REMARK ------------- <CAPACITOR> C301 C302 C303 C304 C305 1-124-584-00 1-163-235-11 1-163-257-11 1-163-021-91 1-163-133-00 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100MF 22PF 180PF 0.01MF 470PF 20% 5% 5% 10% 5% 6.3V 50V 50V 50V 50V C306 C307 C308 C309 C310 1-164-004-11 1-135-181-21 1-163-137-00 1-164-004-11 1-163-021-91 CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 4.7MF 680PF 0.1MF 0.01MF 10% 20% 5% 10% 10% 25V 6.3V 50V 25V 50V C312 C313 C314 C401 C402 1-163-038-91 1-163-009-11 1-135-181-21 1-163-021-91 1-124-259-11 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP ELECT 0.1MF 0.001MF 4.7MF 0.01MF 4.7MF 10% 20% 10% 20% 25V 50V 6.3V 50V 35V C403 C404 C405 C406 C407 1-104-847-11 1-163-021-91 1-126-153-11 1-126-153-11 1-124-589-11 TANTAL. CHIP CERAMIC CHIP ELECT ELECT ELECT 22MF 0.01MF 22MF 22MF 47MF 20% 10% 20% 20% 20% 4V 50V 6.3V 6.3V 6.3V C408 C409 C410 C411 C412 1-163-021-91 1-164-004-11 1-164-004-11 1-164-005-11 1-164-005-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01MF 0.1MF 0.1MF 0.47MF 0.47MF 10% 10% 10% 50V 25V 25V 25V 25V C413 C414 C415 C416 C418 1-163-251-11 1-163-251-11 1-124-584-00 1-163-021-91 1-163-021-91 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 100PF 100PF 100MF 0.01MF 0.01MF 5% 5% 20% 10% 10% 50V 50V 6.3V 50V 50V C419 C420 C421 C422 C423 1-164-004-11 1-163-229-11 1-163-235-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1MF 12PF 22PF 0.001MF 0.001MF 10% 5% 5% 10% 10% 25V 50V 50V 50V 50V C424 C425 C427 C428 C429 1-163-009-11 1-135-210-11 1-163-021-91 1-163-021-91 1-163-021-91 CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001MF 4.7MF 0.01MF 0.01MF 0.01MF 10% 20% 10% 10% 10% 50V 10V 50V 50V 50V C430 C434 C501 C502 C504 1-163-021-91 1-163-021-91 1-163-021-91 1-124-584-00 1-135-259-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT TANTAL. CHIP 0.01MF 0.01MF 0.01MF 100MF 10MF 10% 10% 10% 20% 20% 50V 50V 50V 10V 6.3V C505 C506 C507 1-124-584-00 ELECT 100MF 1-163-038-91 CERAMIC CHIP 0.1MF 1-164-222-11 CERAMIC CHIP 0.22MF 20% 6.3V 25V 25V DESCRIPTION ------------------- REMARK ------------- When indicating parts by reference number, please include the board name. • CAPACITORS PF : µµ F • There are some cases the reference number on one board overlaps on the other board. Therefore, when ordering parts by the reference number, please include the board name. REF. NO. ------------ PART NO. ------------- DESCRIPTION ------------------<CONNECTOR> REMARK ------------- CN502 1-770-606-11 CONNECTOR, BOARD TO BOARD 12P <DIODE> D301 D401 D402 D403 D404 8-719-404-50 8-719-059-51 8-719-404-50 8-719-404-50 8-719-404-50 DIODE MA111-TX DIODE MA3J142E0LSO DIODE MA111-TX DIODE MA111-TX DIODE MA111-TX D405 D406 D501 D502 8-719-404-50 8-719-018-04 8-719-800-76 8-719-800-76 DIODE MA111-TX DIODE MA8240-TX DIODE 1SS226 DIODE 1SS226 <IC> IC301 IC401 IC501 8-759-332-45 IC M52045FP 8-759-368-68 IC A71-2980 8-759-046-84 IC NJM2070M <JACK> J501 1-563-282-11 JACK, SMALL TYPE <COIL> L501 1-412-935-11 INDUCTOR 0.47UH <TRANSISTOR> Q302 Q303 Q401 Q402 Q403 8-729-424-76 8-729-422-37 8-729-422-29 8-729-402-32 8-729-902-99 TRANSISTOR UN2210 TRANSISTOR 2SB709A-R TRANSISTOR 2SD601A-S TRANSISTOR 2SD1819A-R TRANSISTOR DTC114TK Q406 Q407 Q408 8-729-427-74 TRANSISTOR XP4601 8-729-427-74 TRANSISTOR XP4601 8-729-420-44 TRANSISTOR UN5210 <RESISTOR> R301 R302 R303 R304 R305 1-216-085-00 1-216-091-00 1-216-041-00 1-216-061-00 1-216-077-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 33K 56K 470 3.3K 15K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R307 R308 R309 R310 R311 1-216-091-00 1-216-077-00 1-216-001-00 1-216-093-91 1-216-101-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 56K 15K 10 68K 150K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R312 1-216-043-91 RES,CHIP 560 5% 1/10W – 28 – The components identified by shading and mark ! are critical for safety. Replace only with part number specified. B A PART NO. ------------1-216-113-00 1-216-097-91 1-216-081-00 1-216-109-00 DESCRIPTION ------------------RES,CHIP RES,CHIP RES,CHIP RES,CHIP REMARK ------------1/10W 1/10W 1/10W 1/10W 470K 100K 22K 330K 5% 5% 5% 5% R317 R318 R320 R322 R323 1-216-065-91 1-216-687-11 1-216-053-00 1-216-695-11 1-216-129-00 RES,CHIP METAL CHIP RES,CHIP METAL CHIP RES,CHIP 4.7K 33K 1.5K 68K 2.2M 5% 0.50% 5% 0.50% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R324 R325 R327 R401 R402 1-216-073-00 1-216-071-00 1-216-295-91 1-216-099-00 1-216-095-00 RES,CHIP RES,CHIP SHORT RES,CHIP RES,CHIP 10K 8.2K 0 120K 82K 5% 5% 1/10W 1/10W 5% 5% 1/10W 1/10W R403 R404 R405 R406 R407 1-216-017-91 1-216-083-00 1-216-093-91 1-216-035-00 1-216-659-11 RES,CHIP RES,CHIP RES,CHIP RES,CHIP METAL CHIP 47 27K 68K 270 2.2K 5% 5% 5% 5% 0.50% 1/10W 1/10W 1/10W 1/10W 1/10W R408 R409 R410 R411 R412 1-216-660-11 1-216-093-91 1-216-689-11 1-216-121-91 1-216-081-00 METAL CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 2.4K 68K 39K 1M 22K 0.50% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R413 R414 R415 R416 R417 1-216-081-00 1-216-081-00 1-216-081-00 1-216-001-00 1-216-065-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 22K 22K 22K 10 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R418 R419 R420 R421 R422 1-216-053-00 1-216-073-00 1-216-049-91 1-216-073-00 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1.5K 10K 1K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R423 R424 R427 R428 R429 1-216-069-00 1-216-059-00 1-216-049-91 1-216-083-00 1-216-025-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 6.8K 2.7K 1K 27K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R430 R431 R432 R436 R447 1-216-025-91 1-216-025-91 1-216-025-91 1-216-073-00 1-216-073-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100 100 100 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R501 R502 R503 R504 R505 1-216-308-00 1-216-142-00 1-216-142-00 1-216-041-00 1-216-041-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 4.7 4.7 4.7 470 470 5% 5% 5% 5% 5% 1/10W 1/8W 1/8W 1/10W 1/10W R506 R509 R510 1-216-039-00 RES,CHIP 1-216-099-00 RES,CHIP 1-216-073-00 RES,CHIP 390 120K 10K 5% 5% 5% 1/10W 1/10W 1/10W <RESISTOR BLOCK> RB401 RB402 RB403 RB404 RB405 1-233-788-11 1-233-788-11 1-233-788-11 1-233-788-11 1-233-788-11 RES, NETWORK 2.2K RES, NETWORK 2.2K RES, NETWORK 2.2K RES, NETWORK 2.2K RES, NETWORK 2.2K <VARIABLE RESISTOR> RV301 RV401 RV402 RV501 1-223-587-11 1-223-901-21 1-223-587-11 1-223-900-21 RES, ADJ, CARBON 22K RES, VAR 50K RES, ADJ, CARBON 22K RES, VAR 10K --------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------- REF. NO. -----------R313 R314 R315 R316 REF. NO. ------------ PART NO. ------------- DESCRIPTION ------------------<CRYSTAL> REMARK ------------- X301 X401 1-567-505-41 OSCILLATOR, CRYSTAL 1-760-601-21 VIBRATOR, CRYSTAL ************************************************************* – 29 – * A-1297-491-A A BOARD, COMPLETE ********************* <CAPACITOR> C001 C002 C003 C004 C005 1-124-259-11 1-126-153-11 1-163-135-00 1-124-589-11 1-163-021-91 ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP 4.7MF 22MF 560PF 47MF 0.01MF 20% 20% 5% 20% 10% C006 C007 C008 C010 C011 1-164-005-11 1-163-009-11 1-164-005-11 1-163-021-91 1-126-157-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.47MF 0.001MF 0.47MF 0.01MF 10MF C012 C014 C015 C016 C106 1-164-005-11 1-164-005-11 1-163-251-11 1-164-005-11 1-163-021-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47MF 0.47MF 100PF 0.47MF 0.01MF C109 C110 C203 C204 C205 1-163-021-91 1-163-021-91 1-163-038-91 1-163-021-91 1-135-181-21 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP 0.01MF 0.01MF 0.1MF 0.01MF 4.7MF 10% 20% 50V 50V 25V 50V 6.3V C206 C207 C208 C209 C210 1-163-237-11 1-163-243-11 1-163-085-00 1-163-021-91 1-163-021-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 27PF 47PF 2PF 0.01MF 0.01MF 5% 5% 0.25PF 10% 10% 50V 50V 50V 50V 50V C211 C212 C213 C215 C216 1-163-021-91 1-163-021-91 1-163-021-91 1-124-589-11 1-163-021-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.01MF 0.01MF 0.01MF 47MF 0.01MF 10% 10% 10% 20% 10% 50V 50V 50V 6.3V 50V C218 C219 C220 C222 C223 1-163-021-91 1-135-145-11 1-135-149-21 1-135-259-11 1-135-145-11 CERAMIC CHIP TANTAL. CHIP TANTAL. CHIP TANTAL. CHIP TANTAL. CHIP 0.01MF 0.47MF 2.2MF 10MF 0.47MF 10% 20% 20% 20% 20% 50V 25V 6.3V 6.3V 25V C224 C225 C226 C227 C228 1-163-021-91 1-163-021-91 1-163-021-91 1-163-021-91 1-163-021-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01MF 0.01MF 0.01MF 0.01MF 0.01MF 10% 10% 10% 10% 10% 50V 50V 50V 50V 50V C234 C235 C601 C603 C604 1-163-021-91 1-163-009-11 1-124-584-00 1-164-004-11 1-163-017-00 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 0.01MF 0.001MF 100MF 0.1MF 0.0047MF 10% 10% 20% 10% 10% 50V 50V 10V 25V 50V C605 C610 C611 C612 C613 1-163-243-11 1-163-133-00 1-124-261-00 1-163-021-91 1-127-561-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT 47PF 470PF 10MF 0.01MF 33MF 5% 5% 20% 10% 20% 50V 50V 50V 50V 10V C614 C615 C616 C617 C619 1-163-021-91 1-163-021-91 1-163-021-91 1-124-584-00 1-163-017-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.01MF 0.01MF 0.01MF 100MF 0.0047MF 10% 10% 10% 20% 10% 50V 50V 50V 6.3V 50V 10% 10% 20% 5% 10% 10% 10% 16V 6.3V 50V 6.3V 50V 25V 50V 25V 50V 6.3V 25V 25V 50V 25V 50V The components identified by shading and mark ! are critical for safety. Replace only with part number specified. A CF201 CF202 CF203 PART NO. ------------- DESCRIPTION ------------------<FILTER> REMARK ------------- 1-409-332-00 CERAMIC TRAP 1-760-642-11 DISCRIMINATOR, CERAMIC 1-577-559-21 FILTER, CERAMIC <CONNECTOR> CN201 CN601 * 1-770-605-11 CONNECTOR, BOARD TO BOARD 12P * 1-770-590-11 PIN, CONNECTOR (PC BOARD) <DIODE> D001 D002 D601 D602 D603 8-719-801-78 8-719-800-76 8-719-421-82 8-719-027-72 8-719-048-98 DIODE 1SS184 DIODE 1SS226 DIODE MA8043-M DIODE MA199-(TX) DIODE RB160L-40TE25 D604 D605 8-719-018-15 DIODE MA8360 8-719-404-50 DIODE MA111-TX <FUSE> F601 ! 1-533-631-31 FUSE, MICRO <IC> IC001 IC201 8-759-332-43 IC AN5707NFAP 8-759-176-91 IC M51348AFP <COIL> L201 L205 L208 L601 1-412-008-31 1-410-992-11 1-412-029-11 1-412-031-11 INDUCTOR CHIP 15UH INDUCTOR CHIP 0.82UH INDUCTOR CHIP 10UH INDUCTOR CHIP 47UH <TRANSISTOR> Q001 Q002 Q003 Q004 Q006 8-729-422-37 8-729-402-84 8-729-424-76 8-729-424-38 8-729-422-54 TRANSISTOR 2SB709A-R TRANSISTOR XN4601 TRANSISTOR UN2210 TRANSISTOR UN2110 TRANSISTOR XN4215 Q007 Q201 Q202 Q203 Q601 8-729-424-45 8-729-031-37 8-729-422-37 8-729-424-76 8-729-422-29 TRANSISTOR UN211D-TX TRANSISTOR 2SC3837KQ TRANSISTOR 2SB709A-R TRANSISTOR UN2210 TRANSISTOR 2SD601A-S Q602 Q603 Q610 8-729-422-29 TRANSISTOR 2SD601A-S 8-729-421-15 TRANSISTOR 2SD1119-Q 8-729-422-37 TRANSISTOR 2SB709A-R R001 R002 R003 R004 R005 1-216-099-00 1-216-095-00 1-216-091-00 1-216-089-91 1-216-101-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 120K 82K 56K 47K 150K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R008 R009 R010 R011 R012 1-218-762-11 1-216-687-11 1-216-308-00 1-216-073-00 1-216-109-00 METAL CHIP METAL CHIP RES,CHIP RES,CHIP RES,CHIP 270K 33K 4.7 10K 330K 0.50% 0.50% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R013 R014 R015 R016 R017 1-216-091-00 1-216-689-11 1-216-073-00 1-216-689-11 1-216-079-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 56K 39K 10K 39K 18K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W <RESISTOR> --------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------- REF. NO. ------------ REF. NO. -----------R018 R019 R020 R021 R022 PART NO. ------------1-216-097-91 1-216-107-00 1-216-113-00 1-216-097-91 1-216-089-91 DESCRIPTION ------------------RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100K 270K 470K 100K 47K 5% 5% 5% 5% 5% REMARK ------------1/10W 1/10W 1/10W 1/10W 1/10W R024 R029 R031 R032 R111 1-216-089-91 1-216-041-00 1-216-105-91 1-216-057-00 1-216-001-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 47K 470 220K 2.2K 10 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R201 R202 R205 R206 R208 1-216-045-00 1-216-033-00 1-216-097-91 1-216-045-00 1-216-045-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 680 220 100K 680 680 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R209 R210 R212 R213 R215 1-216-055-00 1-216-085-00 1-216-037-00 1-216-073-00 1-216-009-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1.8K 33K 330 10K 22 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R216 R217 R218 R219 R220 1-216-051-00 1-216-039-00 1-216-021-00 1-216-039-00 1-216-017-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1.2K 390 68 390 47 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R221 R222 R223 R224 R225 1-216-049-91 1-216-071-00 1-216-049-91 1-216-053-00 1-216-063-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 1K 8.2K 1K 1.5K 3.9K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R226 R228 R229 R230 R231 1-216-061-00 1-216-073-00 1-216-071-00 1-216-001-00 1-216-009-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 3.3K 10K 8.2K 10 22 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R240 R241 R242 R243 R601 1-216-073-00 1-216-103-00 1-216-041-00 1-216-081-00 1-216-091-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 10K 180K 470 22K 56K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R602 R603 R604 R605 R606 1-216-089-91 1-216-009-91 1-216-037-00 1-216-025-91 1-216-295-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP SHORT 47K 22 330 100 0 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R608 R610 R611 R612 R613 1-216-091-00 1-216-025-91 1-216-051-00 1-216-033-00 1-216-043-91 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 56K 100 1.2K 220 560 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R614 R615 R616 1-216-085-00 RES,CHIP 1-216-073-00 RES,CHIP 1-216-051-00 RES,CHIP 33K 10K 1.2K 5% 5% 5% 1/10W 1/10W 1/10W <VARIABLE RESISTOR> RV001 RV002 RV003 RV004 RV201 1-223-588-11 1-223-588-11 1-223-598-11 1-223-598-11 1-223-583-11 RES, ADJ, CARBON 47K RES, ADJ, CARBON 47K RES, VAR, CARBON 100K RES, VAR, CARBON 100K RES, ADJ, CARBON 1K RV601 1-223-581-11 RES, ADJ, CARBON 220 <SWITCH> S001 S002 S601 – 30 – 1-571-532-21 SWITCH, TACTIL 1-571-532-21 SWITCH, TACTIL 1-762-368-11 SWITCH, SLIDE The components identified by shading and mark ! are critical for safety. Replace only with part number specified. PART NO. ------------- DESCRIPTION ------------------<FILTER> SWF201 1-760-373-11 SAWF REMARK ------------- <TRANSFORMER> T201 T202 T601 1-411-278-11 COIL 1-411-278-11 COIL 1-427-919-11 TRANSFORMER, DC-DC CONVERTER <TUNER> TU101 ! 1-693-219-11 TUNER UNIT (TEPA5) ************************************************************* * A-1394-649-A L BOARD, COMPLETE ********************* <CAPACITOR> C701 C702 C703 1-126-924-11 ELECT 1-111-262-11 FILM 1-109-878-11 CERAMIC 330MF 0.15MF 15PF 20% 5% 5% 10V 50V 2KV <DIODE> D701 D702 D703 D704 8-719-970-02 8-719-991-33 8-719-991-33 8-719-970-02 DIODE 1SR139-400 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE 1SR139-400 <JACK> J701 1-568-907-21 JACK,DC(POLARITY UNIFIED TYPE) L701 1-412-537-31 INDUCTOR 100UH <COIL> <TRANSISTOR> Q701 Q702 8-729-140-96 TRANSISTOR 2SD774-34 8-729-140-96 TRANSISTOR 2SD774-34 <RESISTOR> R701 R702 1-249-411-11 CARBON 1-247-807-31 CARBON 330 100 5% 5% 1/4W 1/4W <TRANSFORMER> T701 1-427-918-11 TRANSFORMER, CONVERTER ************************************************************* --------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------- REF. NO. ------------ A L REF. NO. ------------ PART NO. ------------- DESCRIPTION ------------------MISCELLANEOUS ***************** 1-501-767-11 1-504-847-11 1-517-425-11 1-810-873-11 ANTENNA, STRAP SPEAKER (2.8CM) LIGHT, BACK MODULE, INDICATOR REMARK ------------- ************************************************************* – 31 – ACCESSORIES AND PACKING MATERIALS **************************************** * 4-048-191-02 HOLDER * 4-048-192-01 BLISTER 4-561-210-01 CARD BOARD FDL-22 Sony Ichinomiya Corporation 9-965-032-11 Quality Assurance Division – 32 – English 99BM08091-1 Printed in Japan © 1999. 2
