Download Sharp CD-C662 Service manual
Transcript
CD-C662 SERVICE MANUAL No. S4917CDC662// CD-C662 CD-C662 mini component system consisting of CD-C662 (Main unit) and CP-C662 and (Speaker system). • In the interests of user-safety the set should be restored to its original condition and only parts identical to those specified be used. CONTENTS Page IMPORTANT SERVICE NOTES (FOR U.S.A. ONLY) ....................................................................................................... 2 SPECIFICATIONS ............................................................................................................................................................. 2 NAMES OF PARTS ........................................................................................................................................................... 3 OPERATION MANUAL ...................................................................................................................................................... 5 QUICK GUIDE (FOR U.S.A. ONLY) .................................................................................................................................. 6 DISASSEMBLY .................................................................................................................................................................. 7 REMOVING AND REINSTALLING THE MAIN PARTS ................................................................................................... 10 ADJUSTMENT ................................................................................................................................................................. 10 NOTES ON SCHEMATIC DIAGRAM .............................................................................................................................. 13 WAVEFORMS OF CD CIRCUIT ...................................................................................................................................... 14 BLOCK DIAGRAM ........................................................................................................................................................... 15 SCHEMATIC DIAGRAM/WIRING SIDE OF P.W.BOARD ................................................................................................ 18 TROUBLESHOOTING (CD SECTION) ........................................................................................................................... 36 FUNCTION TABLE OF IC ................................................................................................................................................ 41 FL DISPLAY ...................................................................................................................................................................... 48 REPLACEMENT PARTS LIST/EXPLODED VIEW PACKING OF THE SET (FOR U.S.A. ONLY) SHARP CORPORATION –1– This document has been published to be used for after sales service only. The contents are subject to change without notice. CD-C662 FOR A COMPLETE DESCRIPTION OF THE OPERATION OF THIS UNIT, PLEASE REFER TO THE OPERATION MANUAL. IMPORTANT SERVICE NOTES (FOR U.S.A. ONLY) BEFORE RETURNING THE AUDIO PRODUCT (Fire & Shock Hazard) Before returning the audio product to the user, perform the following safety checks. 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the audio product. 2. Inspect all protective devices such as insulating materials, cabinet, terminal board, adjustment and compartment covers or shields, mechanical insulators etc. 3. To be sure that no shock hazard exists, check for leakage current in the following manner. * Plug the AC line cord directly into a 120 volt AC outlet. * Using two clip leads, connect a 1.5k ohm, 10 watt resistor paralleled by a 0.15µF capacitor in series with all exposed metal cabinet parts and a known earth ground, such as conduit or electrical ground connected to earth ground. * Use a VTVM or VOM with 1000 ohm per volt, or higher, sensitivity to measure the AC voltage drop across the resistor (See diagram). * Connect the resistor connection to all exposed metal parts having a return path to the chassis (antenna, metal cabinet, screw heads, knobs and control shafts, escutcheon, etc.) and measure the AC voltage drop across the resistor. VTVM AC SCALE 1.5k ohms 10W 0.15 µ F TO EXPOSED METAL PARTS TEST PROBE CONNECT TO KNOWN EARTH GROUND All check must be repeated with the AC line cord plug connection reversed. Any reading of 0.3 volt RMS (this corresponds to 0.2 milliamp. AC.) or more is excessive and indicates a potential shock hazard which must be corrected before returning the audio product to the owner. SPECIFICATIONS CD-C662 General Power source: Power consumption: Dimensions: Weight: Amplifier section Output power: Output terminals: Input terminal: Tuner section Frequency range: Compact disc player section Type: 3-disc multi-play compact disc player Signal readout: Non-contact, 3-beam semiconductor laser pickup D/A Converter: 1-bit D/A converter Frequency response: 20 - 20,000 Hz Dynamic range: 90 dB (1 kHz) AC 120 V, 60 Hz Stand-by; 0.3 W Power on; 210 W Width; 10-5/8" (270 mm) Height; 13" (330 mm) Depth; 14-1/8" (358 mm) 22.0 lbs. (10.0 kg) CP-C662 150 watts minimum RMS per channel into 6 ohms from 60 Hz to 20 kHz, 10 % total harmonic distortion Speakers; 6 ohms Headphones; 16-50 ohms (recommended; 32 ohms) CD digital output (optical) Video/Auxiliary (audio signal); 500 mV/47 kohms Speaker section Type: Maximum input power: Rated input power: Impedance: Dimensions: Weight: FM; 87.5 - 108 MHz AM; 530 - 1,720 kHz 2-way type [7-7/8" (200 mm) woofer and 3-1/8" (80 mm) tweeter] 300 W 150 W 6 ohms Width; 9-13/16" (250 mm) Height; 13" (330 mm) Depth; 13-1/14" (335 mm) 13.4 lbs. (6.1 kg)/each Specifications for this model are subject to change without prior notice. Cassette deck section Frequency response: 50 - 14,000 Hz (Normal tape) Signal/noise ratio: 55 dB (TAPE 1, playback) 50 dB (TAPE 2, recording/ playback) Wow and flutter: 0.15 % (WRMS) –2– CD-C662 NAMES OF PARTS 1 CD-C662 2 3 45 Front Panel 1. Disc Number Selector Buttons 2. Disc Tray 3. Multi Indicator 4. Disc Skip Button 5. Open/Close Button 6 7 8 6. Extra Bass Indicator 7. FM Stereo Mode Indicator 8. FM Stereo Indicator 9. (CD) Repeat Indicator 10. (CD) Play Indicator 11. (CD) Pause Indicator 12. Spectrum Analyzer/Volume Level Indicator 13. (TAPE 2) Record Indicator 14. (CD) Disc Number Indicators 15. (CD/TUNER) Memory Indicator 16. Timer Play Indicator 17. Timer Record Indicator 18. Sleep Indicator 19. (CD) Track Down/Review Button (TUNER) Preset Down Button (TAPE 2) Rewind Button 20. (CD/TAPE) Stop Button 21. (TAPE) Play Button (CD) Play/Repeat Button 22. (CD) Track Up/Cue Button (TUNER) Preset Up Button (TAPE 2) Fast Forward Button 23. Timer/Sleep Button 24. Clock Button 25. Timer Set Indicator 26. Power Button 27. Function Selector Buttons 28. Equalizer Mode Selector Button 29. Dimmer Button 30. Extra Bass/Demo Mode Button 31. Headphones Socket 32. (TAPE 2) Record Pause Button 33. Memory/Set Button 34. Tuning and Time Up/Cue Buttons 35. Volume Control 19 9 10 11 12 13 14 20 15 16 17 18 21 22 23 28 24 29 25 30 26 27 31 32 33 36 34 35 37 36. (TAPE 1) Cassette Compartment 37. (TAPE 2) Cassette Compartment Rear Panel 38. CD Digital Output Socket 39. AC power lead 40. FM/AM Loop Aerial Socket 41. Video/Auxiliary (Audio Signal) Input Sockets 42. Speaker Terminals 38 40 39 41 42 –3– CD-C662 CP-C662 Front Speaker 1. Tweeter 2. Woofer 3. Bass Reflex Ducts 4. Speaker Terminals 1 3 4 2 Remote Control 1. Remote Control Transmitter LED 1 CD Control section 2. Disc Number Select Buttons 3. Memory Button 4. Pause Button 5. Clear Button 6. Track Down/Review Button 7. Track Up/Cue Button 8. Disc Skip Button 9. Play/Repeat Button 10. Stop Button 11. Random Button Tuner control section 12. Preset Up/Down Buttons Tape control section 13. (TAPE 1) Play Button 14. (TAPE 2) Record Pause Button 15. (TAPE 1/2) Stop Button 16. (TAPE 2) Play Button 17. (TAPE 2) Rewind Button 18. (TAPE 2) Fast Forward Button 2 8 3 9 4 5 6 7 10 11 12 13 14 15 16 17 18 19 20 Common section 19. Equalizer Mode Selector Button 20. Function Selector Buttons 21. Power Button 22. Extra Bass Button 23. Volume Up/Down Buttons 21 22 –4– 23 –5– 9 8 7 6 5 4 3 2 AM 12:00 POWER MEMORY/ SET CLOCK AM 0:00 0:00 TUNING/ TIME ( ) In this example, the clock is set for the 12-hour (AM 12:00) system. (Main unit operation) SETTING THE CLOCK or ) button to adjust the hour. or ) button to adjust the The clock starts operating from "0" seconds. (Seconds are not displayed.) Press the MEMORY/SET button. Press the TUNING/TIME ( or ) button once to advance the time by 1 minute. Hold it down to change the time in 5 minute intervals. The hour setting will not advance even if minutes advance from "59" to "00". Press the TUNING/TIME ( minutes. Press the MEMORY/SET button. Press the TUNING/TIME ( or ) button once to advance the time by 1 hour. Hold it down to advance continuously. When the 12-hour display is selected, "AM" will change automatically to "PM". Press the TUNING/TIME ( Press the MEMORY/SET button. Press the TUNING/TIME ( or ) button to select the time display mode. "AM 12:00" → The 12-hour display will appear. . (AM 12:00 - PM 11:59) "AM 0:00" → The 12-hour display will appear. (AM 0:00 - PM 11:59) "0:00" → The 24-hour display will appear. (0:00 - 23:59) Note that this can only be set when the unit is first installed or it has been reset. Within 5 seconds, press the MEMORY/SET button. Press the CLOCK button. Press the POWER button to enter the stand-by mode. 2 Perform steps 1 - 9 above. MICROCOMPUTER", on page 15. To change the time display mode: 1 Perform steps 1 - 2 in the section "RESETTING THE Press the CLOCK button. The time display will appear for about 5 seconds. To see the time display: 3 Perform steps 6 - 9 above. 2 Within 5 seconds, press the MEMORY/SET button. 1 Press the CLOCK button. To change the clock time: Note: In the event of a power failure or when the AC power cord is disconnected, the clock display will go out. When the AC power supply is restored, the clock display will flash on and off to indicate the time when the power failure occurred or when the AC power cord was disconnected. If this happens, follow the procedure below to change the clock time. 9 7 8 5 6 1 2 3 4 1,2 2 RESETTING THE MICROCOMPUTER While pressing down the button and the button, hold down the POWER button for at least 1 second. Press the POWER button to enter the stand-by mode. Caution: The operation explained above will erase all data stored in memory including clock and timer settings, and tuner and CD presets. 1 2 Reset the microcomputer under the following conditions: To erase all of the stored memory contents (clock and timer settings, and tuner and CD presets). If the display is not correct. If the operation is not correct. CD-C662 OPERATION MANUAL FM/AM loop antenna x 1 Antena de cuadro de FM/AM x 1 –6– AC 120 V, 60 Hz 120 V de CA, 60 Hz AM Loop Antenna Antena de cuadro de AM POWER Turning the power on and off Conexión y desconexión de la alimentación FM Antenna Antena de FM Antenna connection Conexión de las antenas LEFT Red Rojo 15 15 Remote Sensor Sensor remoto 8” - 20’ (0.2m - 6m) 0,2m - 6m Black Negro RATED SPEAKER INPEDANCE : 6 OHMS MIN. RIGHT Batteries are not included. Las pilas no están incluidas. 2 “AA” batteries Dos pilas “AA” Red Rojo SPEAKERS Black Negro Remote control Controlador remoto Red Rojo Right speaker Altavoz derecho Left speaker Altavoz izquierdo Speaker wire x 2 Cable de altavoz x 2 Speaker connection Conexión de los altavoces 2 Preparation for use / Preparación para su uso Remote control x 1 Controlador remoto x 1 1 Check the supplied accessories / Compruebe los accesorios suministrados MINI COMPONENT SYSTEM Quick Guide/Guía rápida CD-C662 TAPE 2 To stop the playback Para detener la reproducción To stop the playback Para detener la reproducción TAPE 2 Volume Volumen VOLUME CD recording starts. La grabación de CD empieza. Extra bass (X-BASS) Graves extra (X-BASS) 7 Sound control / Control del sonido Load the disc to be recorded. Introduzca el disco que va a grabar. SOFT-2 FLAT SOFT-1 HEAVY-1 VOCAL HEAVY-2 Pre-programmed equalizer Ecualizador preprogramado To stop the recording Para detener la grabación 6 Recording from CDs / Grabaciones de discos CD 5 Listening to the radio / Audición de la radio TAPE 1 4 Listening to a tape / Audición de una cinta Label facing up Etiqueta hacia arriba 3 Listening to a CD / Audición de discos CD CD-C662 CD-C662 DISASSEMBLY Caution on Disassembly Follow the below-mentioned notes when disassembling the unit and reassembling it, to keep it safe and ensure excellent performance: 1. Take cassette tape and compact disc out of the unit. 2. Be sure to remove the power supply plug from the wall outlet before starting to disassemble the unit. 3. Take off nylon bands or wire holders where they need to be removed when disassembling the unit. After servicing the unit, be sure to rearrange the leads where they were before disassembling. 4. Take sufficient care on static electricity of integrated circuits and other circuits when servicing. CD-C662 Top Cabinet Front Panel (A1)x2 ø3x12mm Side Panel (Right) (B1)x2 ø3x10mm CD-C662 STEP REMOVAL PROCEDURE FIGURE 1 Top Cabinet 1. Screw ..................... (A1) x4 7-1 2 Side Panel (Left/right) 1. Screw ..................... (B1) x8 7-1 3 CD Player Unit/ CD Tray Cover 1. Turn on the power supply, open the disc tray, take out the CD cover, and close. (Note 1) 2. Screw ..................... (C1) x1 3. Hook ....................... (C2) x3 4. Hook ....................... (C3) x2 5. Socket .................... (C4) x3 7-2 Side Panel (Left) (A1)x2 ø3x12mm Back Board (B1)x2 ø3x10mm (B1)x4 ø3x10mm Figure 7-1 CD Tray Cover (C3) x1 4 Rear Panel (with Digital Output PWB) 1. Screw ..................... (D1) x5 7-2 5 Main PWB 1. Screw ..................... (E1) x1 2. Socket .................... (E2) x4 3. Flat Cable .............. (E3) x1 8-1 Pull Hook (C2) x3 1 (C4) x3 1 6 Front Panel 1. Screw ..................... (F1) x3 2. Socket .................... (F2) x1 8-1 7 Power Amp. PWB 1. Screw ..................... (G1) x7 2. Socket .................... (G2) x2 3. PWB Holder ........... (G3) x1 8-2 8 Power Supply PWB 1. Screw ..................... (H1) x4 8-2 9 Display PWB/ Switch PWB 1. Screw ..................... (J1) x13 2. Socket .................... (J2) x1 8-3 10 Tape Mechanism 1. Open the cassette holder. 2. Screw...................... (K1) x6 8-3 11 Turntable 1. Screw ..................... (L1) x1 2. Cover ..................... (L2) x1 8-4 12 Disc Tray 1. Screw ..................... (M1) x2 2. Guide ..................... (M2) x2 8-4 13 CD Servo PWB (Note 2) 1. Screw ..................... (N1) x1 2. Socket .................... (N2) x4 8-5 14 CD Changer Mechanism 1. Screw ..................... (P1) x4 8-6 15 CD Mechanism 1. Screw ..................... (Q1) x1 8-6 CD Player Unit 2 (C3) x1 (C1) x1 ø3x10mm (D1) x3 ø3x6mm (D1)x1 ø3x10mm (D1) x1 ø3x10mm Rear Panel Figure 7-2 LOCK LEVER Note 1: How to open the changer manually. (Fig. 7-3) 1. Change, turn fully the lock lever in the arrow direction through the hole on the loading chassis bottom in this state. After that, push forward the CD player base. Note 2: 1. After removing the connector for the optical pickup from the connector, wrap the conductive aluminium foil around the front end of connector to protect the optical pickup from electrostatic damage. Figure 7-3 –7– CD-C662 (L1) x1 ø3 x10mm Front Panel (L2) x1 (E2)x2 Washer (E2)x1 (E3)x1 Turntable (F2)x1 Power Supply PWB Main PWB Disc Tray (M1) x1 ø3 x10mm (E1)x1 ø3x10mm (M2) x1 (F1)x3 ø3x10mm Power Amp. PWB (M1) x1 ø3 x10mm Main (E2)x1 PWB Power Amp. PWB CD Player Unit Figure 8-1 (M2) x1 Figure 8-4 (H1)x4 ø4x8mm (N1) x1 ø3 x10mm (G1)x2 ø3x6mm (G1)x5 ø3x10mm CD Servo PWB (G2)x2 (N2) x2 (G3)x1 1 Push Power Supply PWB 1 Push 2 Pull Power Amp. PWB Main Chassis (N2) x2 CD Player Unit Figure 8-5 PowerAmp. PWB (P1) x4 ø3 x12mm Figure 8-2 (J2)x1 (Q1) x1 ø2.6 x10mm Switch PWB Front Panel (J1)x2 ø3x10mm Shift Lever CD Changer Mechanism (J1)x11 ø3x10mm Display PWB Open Cassette Holder (K1)x6 ø3x10mm CD Player Base CD Mechanism Be careful when installing the CD changer mechanism. Install the CD changer mechanism on the CD player base after the shift lever has been set in the highest position. Tape Mechanism Figure 8-3 Figure 8-6 –8– CD-C662 CP-C662 STEP 1 PROCEDURE REMOVAL Front Panel 1. Net .......................... 2. Rubber ................... 3. Screw ..................... 4. Tip .......................... FIGURE (A1) x1 (A2) x4 (A3) x4 (A4) x2 9-1 9-2 2 Woofer 1. Screw ..................... (B1) x4 9-2 3 Tweeter 1. Screw ..................... (C1) x4 9-2 Front Panel Front Panel (A1)x1 Tweeter (C1)x4 ø3x10mm (A4)x2 (A3)x4 ø4x16mm Woofer (B1)x4 ø4x16mm (A2)x4 Figure 9-1 Figure 9-2 –9– CD-C662 REMOVING AND REINSTALLING THE MAIN PARTS CD MECHANISM SECTION Loading/Up/Down Motor Perform steps 1, 2, 3, 11, 12, 13, 14 and 15 of the disassembly method to remove the CD mechanism. Motor PWB How to remove the loading motor (See Fig. 10-1) 1. Remove the screws (A1) x 2 pcs., to remove the loading motor. (A1) x2 ø2.6 x5mm Figure 10-1 How to remove the pickup (See Fig. 10-2) 1. Remove the screws (B1) x 2 pcs., to remove the shaft (B2). 2. Remove the stop washer (B3) x 1 pc., to remove the gear (B4). 3. Remove the pickup. Stop Washer (B1) x2 (B3) x1 ø2.6 x6mm Pickup Note After removing the connector for the optical pickup from the connector, wrap the conductive aluminium foil around the front end of connector to protect the optical pickup from electrostatic damage. Shaft (B2) x1 CD Mechanism Gear (B4) x1 Figure 10-2 ADJUSTMENT MECHANISM SECTION • Tape Speed • Driving Force Check Torque Meter Specified Value Play: TW-2412 Tape 1: Over 80 g Tape 2: Over 80 g Normal speed • Torque Check Torque Meter Adjusting Point Specified Value MTT-111 Volume in motor. (MM1) 3,000 ± 30 Hz Specified Value Tape 1 Play: TW-2111 Test Tape 30 to 60 g. cm Tape 2 TAPE MECHANISM 30 to 60 g.cm Fast forward: TW-2231 — 60 to 120 g.cm Rewind: TW-2231 — 60 to 120 g.cm MM 1 Motor Volume in motor Figure 10-3 – 10 – Instrument Connection Speaker terminal (Load resistance: 8 ohms) CD-C662 • VCO Frequency TUNER SECTION 98.00 MHz (60 dB) Test Stage Frequency Frequency Display Setting/ Instrument Adjusting Connection Parts IF 450 kHz 1,720 kHz T351 Band Coverage — 530 kHz (fL): T333 *2 1.1 ± 0.1 V Tracking 990 kHz 990 kHz (fL): T331 *1. Input: Antenna, *2. Input: Antenna, *1 *1 Band Coverage — 87.50 MHz RF 98.00 MHz 98.00 MHz (10-30 dB) L303(fL): *1 3.4 V ± 50 mV *2 *1. Input: Antenna, Output: TP301 *2. Input: Antenna, Output: Speaker terminal • Detection Signal generator: 10.7 MHz, FM sweep generator Frequency Frequency Display Detection 10.7 MHz IF 10.7 MHz 98.00 MHz 98.00 MHz Adjusting Parts T352 Instrument Connection State Code Cannot detect puin SW Tray close operation error Tray close operation error Tray open operation error Tray open operation error Disc skip operation error Disc skip operation error 0307 Disc skip operation error Pin 13 of IC303 Input: Pin 1 of IC303 Output: TP302 G T301(Turn Input: Pin 1 of the core of IC301 transformer Output: TP302 T352 fully counterclookwise.) Pin 21 of IC303 D FET : 2SK19 or 2SK54 TO FREQUENCY COUNTER S 10 kΩ Figure 11-2 MAIN PWB 1 BF301 IC301 L303 FM BAND COVERAGE fL R381 T301 FM IF L302 FM RF T351 TP301 AM TRACKING fL 1 T333 AM BAND COVERAGE fL IC303 21 T352 FM DET VR351 VCO AM LOOP ANTENNA T331 AM IF 13 Pin 13, Pin 21 and ground of IC303 Error 0001 0101 0105 0201 0203 0304 0305 CNP301 Test Stage VR351* When a malfunction occurs during CD operation, an error code will be displayed to identify the function in CD operation which failed. Instrument Connection L302 98.00 MHz Instrument Connection CD ERROR CODE DESCRIPTION • FM RF Signal generator: 1 kHz, 75 kHz dev., FM modulated Serring/ Adjusting Point Adjusting Parts * Adjust for 76 kHz ± 200 Hz. Notes: After preparing the test circuit shown in Fig 11-2, connect the Pin 13 , Pin 21 and ground of the IC303 with test circuit, and measure the Value. At this time, apply a standard unmodulated signal input and adjust the VCO. Output: TP302 Output: TP301 Test Stage Frequency Frequency Display Frequency Display Frequency fL: Low-range frequency fH: High-renge frequency • AM IF/RF Signal generator: 400 Hz, 30%, AM modulated R360 TP302 Figure 11-1 ADJUSTMENT POINTS – 11 – CD-C662 TEST MODE • Setting the test mode Any one of test mode can be set by pressing several keys as follows. <REC. PAUSE> + <DISC. SKIP> + <POWER> TEST: CD operation test • TEST mode Function — CD test mode Setting of TEST mode Indication of CD TST mode (Fig. 12-1) IL is not performed. OPEN/CLOSE operation is manual operation. The pickup can be moved by using the ( <MEMORY> LASER ON <MEMORY> Tracking on the spot. SERVO OFF PLAY <PLAY> key input ) or ( ) key. <MEMORY> Tracking on the spot. SERVO ON PLAY <STOP> STOP TOC. IL is performed, and the ordinary PLAY is performed. If the following key is pressed during PLAY, it is possible to specify directly any Track No. <Disc Number 1> key: Track 4 <Disc Number 2> key: Track 9 <Disc Number 3> key: Track 15 Note: Only in STOP state it is possible to slide the pickup with the ( VOL. --- Last memory BAL. --- CENTER R.GEQ. --- FLAT X-BAS --- OFF 1 2 ) or ( Press <STOP> key. Stop ) key. 3 Canceling method - POWER OFF Figure 12-1 CD SECTION Since this CD system incorporates the following automatic adjustment function, when the pickup is replaced, it is not necessary to readjust it. Since this CD unit does not need adjustment, the combination of PWB and laser pickup unit is not restricted. • Automatic adjustment item 1. Focus offset (Fig. 12-2) 2. Tracking offset (Fig. 12-3) 3. E/F balance (tracking error balance) (Fig. 12-4) 4. RF level AGC function (HF level: constant) 5. RF level automatic follow-up of the tracking gain This automatic adjustment is performed each time a disc is changed. Therefore, each disc is played back using the optimal settings. Enlarged View 10ms 0.50 V IC1 20 FE 0.1s 0.50 V IC1 20 FE FOCUS OFF-SET ADJUST 10ms 0.50 V IC1 7 TE 0.1s 0.50 V IC1 7 TE TRACKING OFF-SET 1 ADJUST TRACKING OFF-SET 1 ADJUST 2 2 Figure 12-3 Figure 12-2 TRACKING/ ERROR BARANCE 1 ADJUST 200 ms 1V/diV IC 1 15 TO 200 ms 1V/diV IC 1 7 TE 2 Figure 12-4 – 12 – CD-C662 NOTES ON SCHEMATIC DIAGRAM • Resistor: To differentiate the units of resistors, such symbol as K and M are used: the symbol K means 1000 ohm and the symbol M means 1000 kohm and the resistor without any symbol is ohm-type resistor. Besides, the one with “Fusible” is a fuse type. • Capacitor: To indicate the unit of capacitor, a symbol P is used: this symbol P means micro-micro-farad and the unit of the capacitor without such a symbol is microfarad. As to electrolytic capacitor, the expression “capacitance/withstand voltage” is used. (CH), (TH), (RH), (UJ): Temperature compensation (ML): Mylar type (P.P.): Polypropylene type • Schematic diagram and Wiring Side of P.W.Board for this model are subject to change for improvement without prior notice. REF. NO DESCRIPTION • The indicated voltage in each section is the one measured by Digital Multimeter between such a section and the chassis with no signal given. 1. In the tuner section, ( ) indicates AM < > indicates FM stereo 2. In the main section, a tape is being played back. 3. In the deck section, a tape is being played back. ( ) indicates the record state. 4. In the power section, a tape is being played back. 5. In the CD section, the CD is stopped. • Parts marked with “ ”( ) are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. POSITION REF. NO DESCRIPTION POSITION JOG701 VOLUME JOG ON—OFF SW713 STOP ON—OFF SW1 OPEN/CLOSE ON—OFF SW714 TUNER (BAND) ON—OFF SW2 MECHA UP ON—OFF SW715 VIDEO/AUX ON—OFF SW3 DISC NUMBER ON—OFF SW716 TAPE ON—OFF SW4 PICKUP IN ON—OFF SW717 CD ON—OFF SW701 POWER ON—OFF SW722 FF ON—OFF SW703 CLOCK ON—OFF SW723 TUNING UP ON—OFF SW704 TIMER/SLEEP ON—OFF SW724 TUNING DOWN ON—OFF SW705 DISC 1 ON—OFF SW725 PLAY ON—OFF SW706 DISC 2 ON—OFF SW728 X-BASS/DEMO ON—OFF SW707 DISC 3 ON—OFF SW729 EQUALIZER ON—OFF SW708 DISC SKIP ON—OFF SW730 DIMMER ON—OFF SW709 OPEN/CLOSE ON—OFF SWM 3 FOOL PROOF ON—OFF SW710 REV ON—OFF SWM 4 F.A.S. ON—OFF SW711 REC PAUSE ON—OFF SWM 5 CAM ON—OFF SW712 MEMORY/SET ON—OFF FRONT VIEW FRONT VIEW E C B (S) (G) (D) (1) (2) (3) 2SA1015 GR 2SA1318 2SC3331 2SC535 C KRA102 M KRA109 M KRC102 M KRC104 M KRC107 M KTA1266 KTA1271 KTA1273 KTA1274 KTD2058 KTC3199 KTC3200 KTC3203 GR Y Y Y L1154GT4 SLI342YCB SLI342DCB SLI342UCB SLI342YCJ GR GR Y Figure 13 TYPES OF TRANSISTOR AND LED – 13 – CD-C662 WAVEFORMS OF CD CIRCUIT STOP FOCUS 1 2 PLAY SERCH 5ms 0.50 V IC1 20 F.E 5ms 5.0 V IC1 54 DRF 0.5ms 10.0 V JP+ 7 0.5ms 10.0 V JP- 8 0.5ms 0.50 V JP 9 0.5ms 1.00 V TE 3 1 3 6 PLAY CUE 0.5ms 1.00 V HF 4 0.5ms 5.0 V HFL 1 5 0.5ms 5.0 V TES 3 3 0.5ms 1.00 V HF NORMAL DISC TN0=01 10 20ms 1.00 V SPO 11 20ms 2.00 V CLV+ 2 REVIEW PLAY TCD-712 (140mm) TN0=01 4 5 0.5ms 5.0 V HFL 1 0.5ms 5.0 V TES 3 6 50ms 10.0 V JP+ 7 50ms 10.0 V JP- 8 50ms 0.50 V JP 9 2 0.5ms 10.0 V JP+ 7 0.5ms 10.0 V JP- 8 0.5ms 0.50 V JP 9 0.5ms 1.00 V TE 6 50ms 10.0 V JP+ 7 50ms 10.0 V JP- 8 50ms 0.50 V JP 9 50ms 1.00 V TE 50ms 1.00 V SPO 11 50ms 2.00 V CLV+ CUE PLAY TCD-712 12 50ms 1.00 V TE 6 10 5s 100mV SLD 1 12 0.5s 100mV SLD REVIEW 1 – 14 – – 15 – Figure 15 BLOCK DIAGRAM (1/3) M M PICKUP IN SW4 M1 SPINDLE MOTOR M2 SLED MOTOR TRACKING COIL FOCUS COIL 15 16 26 27 6 7 4 5 23 1 2 3 4 20 25 8 ~ 14 21 22 29 ~ 35 IC3 M63001FP FOCUS/ TRACKING/ SPIN/SLED DRIVER 1 2 7 28 39 38 37 36 20 40 24 18 42 41 30 31 54 15 16 27 23 29 FIN2 FIN1 E F IC1 LA9241M SERVO AMP. 64 VCC1 62 LD0 TO FD SPO NC SLD 22 JP– 32 Q52 CV+ 40 SLC 43 SL1 44 ~ Q1 SL– SL+ DRF PU-IN SW +B5 +B1 SL+. SL–. DRF 6 23 36 41 43 +5V 51 62 ~ 64 20 JP– 53 ~ 58 27 37 38 39 40 31 CONT2 25 CONT1 24 LCHO LVSS RVSS RCHO 26 33 38 39 46 RES. CQCK. COIN SQOUT. RWC. WRQ 10 EFMIN 12 CLV+ IC2 LC78622NE SERVO/SIGNAL 11 CONTROL 9 EFMO 2 4 8 44 XOUT 45 XL1 XIN CL, DAT, SELIAL CONTROL/CE 51 52 53 +B1 ~ +5V CL DAT CE VVDD VDD LVDD RVDD XVDD PICKUP UNIT +4.3V Q51 2 1 BI1B Q81 +5V CNS10 9 8 7 6 5 4 3 2 1 +7.3V (+B1) MECHA UP GND (D) DISK NO. OPEN/CLOSE GND (D) M– M+ GND (M) CNP10 9 8 7 6 5 4 3 2 1 10 SOLM1 M3 LOADING TO MAIN SECTION M SW1 OPEN/CLOSE SW3 DISC No. SW2 MECHA UP TO MAIN SECTION (TO IC601) 10 GND (D) 1 2 3 4 5 6 CNP11 REGULATOR 2 1 BI1A 3 2 1 CNP99 CD-C662 CD-C662 SWM3 FOOL PROOF SWM4 F.A.S SOLM1 SOLENOID AM LOOP FM ANTENNA ANTENNA BF301 IC301 TA7358AP FM FRONT END 1 FM B.P.F FM IF 6 +B4 +B4 CF301 T301 SWM5 CAM 9 4 5 8 7 L302 T351 FM IF IN FM OSC FM RF VR351 MPX VCO ADJ AM IF T352 CF351 1 3 AM MIX 20 22 AM+B AM OSC IN 23 15 13 3 5 VCO MO/ST 7 6 7 11 3 8 20 22 1 OSC 4 CL DI 3 11 5 IC302 LC72131 PLL (TUNER) 7 FM +B 16 CE AM IN 15 FM IN T333 3 IC704 2 1 VOLTAGE REGURATER 6 +B4 17 21 10 FM Q344 SWITCHING JK601 VIDEO/AUX L AUX R TAPE CNS11 TUNER CD IC101 AN7345K PLAYBACK AND RECORD /PLAYBACK AMP. L(T1) 1 R(T1) 24 L-CH R-CH REC P.B L-CH TAPE 2 R-CH REC PB HEAD SWITCHING Q103~Q106 4 L 21 R L NF 3 R NF 4 20 H/N NOR/ HIGH 5 4 17 3 18 2 IC601 M62439SP AUDIO PROCESSOR 19 1 20 +B4 PB Q121 Q122 MUTING L REC R 8 L NF 17 R NF 10 ALC 7 19 Q111 Q109 SWITCHING 9 Q113 Q114 SWITCHING Q107 Q108 10 16 T1/T2 15 SWITCHING L R L R L R L R 18 REF 14 12 –B4 11 5 T1/T2 L REC 9 REC R REC 16 AC BIAS ERASE HEAD 13 P.B. L(T2) 2 R(T2) 23 POP REDUCE 6 BIAS OCS 4 +B5 –B1 FM/AM SWITCHING +B7 X352 4.5MHz TAPE 1 PB HEAD IC562 KIA4558 OPE AM Q343 VT FROM CD SECTION CNP11 4 IC563 KIA4558 OPE AM FM/AM 16 17 AM BAND COVERAGE 1 2 3 8 L 9 R 10 MPX IN DET OUT STEREO 24 AM RF IN FMOSC Q302 OSC BUFF T331 –B MONO/ST 6 5 AM IF GND FM+B FM DET 21 IC303 LA1805 FM/AM IF MPX. AM TRACKING +B5 FM DET L303 DO 3 FM OSC 2 Q110 Q128 L104 SWITCHING BAIS Q124 L103 Q126 Figure 16 BLOCK DIAGRAM (2/3) – 16 – 13 R 8 L 1 CD-C662 FL701 DISPLAY Q702 Q703 M +B5 –B1 8 4 +B5 1 2 3 4 ~ 15 16 ~ 25 26 ~ 28 29 ~ 36 37 38 39 MM1 TAPE MOTOR Q705 Q706 Q707 NO/ST 3 5 IC563 KIA4558P OPE AMP. 1 9 6 7 10 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 IC562 KIA4558P OPE AMP. 8 4 +B7 1 +B5 –B1 1 +B7 1 RX701 3 2 +B7 IC701 IX0280AW SYSTEM CONTROL MICROCOMPUTER VDD 3 50 49 48 47 46 VDD 45 44 43 42 41 40 39 38 37 36 35 34 AVDD 33 32 31 VDD 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 UNSWITCH +B7 MEMORY BACK UP 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 +B5 KEY SW701, SW703~SW717, SW722~SW725, SW728~SW730 TO CD SECTION +B7 PHM1 XL701 4.19MHz Q910 Q911 Q908 Q909 18 22 8 L Q603 Q604 +B5 RL901 Q901 Q902 13 IC901 STK40704 POWER AMP. VH+ VH– VL+ VL– 1 8 7 4 15 L-OUT 14 R-OUT +B1 +B4 +7.3V Q851 FRONT SPEAKER D810 F804 5A/125V Q852 +12V(ANALOG) SO901 SPEAKER TERMINAL Q903 Q904 2 VOLTAGE REGULATOR REC M901 FAN MOTOR JK671 HEADPHONES Q905 Q601 Q602 M Q907 Q704 +B5 –B4 13 R +B1 D809 F801 5A/125V F805 5A/125V VOLTAGE REGULATOR RL801 D811~D814 +B5 +12V(MOTOR) Q853 Q850 VOLTAGE REGULATOR AC POWER SUPPLY CORD VOLTAGE REGULATOR ZD802 D815 ~D817 Q803 T1/T2 T.F Q802 BAIS +B7 F806 2A/250V AC 120V, 60Hz T801 POWER TRANSFORMER UNSWITCH Q801 D802~D805 Figure 17 BLOCK DIAGRAM (3/3) – 17 – T802 POWER TRANSFORMER CD-C662 A MAIN PWB-A1(2/2) FM SIGNAL CD SIGNAL PLAYBACK SIGNAL RECORD SUGNAL C601 4.7/50 P22 2 - E TO POWER AMP.PWB CNP901 10 11 12 13 R_CH GND –15V SP_RLY M_GND M_+12V SP_DET HP-L CH HP_GND HP-R CH HP_RLY C626 0.001 R620 2.2K –B IC601 M62439SP AUDIO PROCESSOR 19 18 17 16 15 14 11 C622 10/50 R626 2.2K C628 0.22 R624 330 R630 560(1/2W) 12 R623 5.6K ZD601 MTZJ2.4B C606 @4.7/50 13 C617 10/50 C619 0.022 1.5K 1.5K 1.5K 1.5K 0.033 0.22 R612 15K C616 4.7P C620 10/50 C618 0.022 10 R602 R604 R606 R608 C612 C614 R610 10K R653 100K C634 8200P R629 560(1/2W) R638 220K R637 220K R625 22K C629 22/25 R628 22K +B –B +B +B +B L601 2.2µH R155 150 +B 0V 0V R103 2.2K R107 47K 0.7V 56 C154 47/16 C156 3.3/50 R136 18K C130 470P C132 0.001 R140 560 R142 C136 56 0.082 C140 0.0033 C142 1/50 R146 10K C145 22/25 C146 220/16 R138 6.8K 8 7 6 5 C121 1/50 R125 5.6K C119 560P 9 10 11 12 C133 22/25 Q103 KTC3200 GR 13 C141 1/50 R145 10K R111 10K H • NOTES ON SCHEMATIC DIAGRAM can be found on page 13. 1 2 3 4 Figure 18 SCHEMATIC DIAGRAM (1/10) – 18 – 5 6 0V R162 14 11.6V 15 R164 56K Hich=CHROME + 56K – NC C115 R117 C113 47/25 1K 330P IC101 AN7345K PLAYBACK AND RECORD/ PLAYBACK AMP. R119 – + ALC RIPPLE 4 16 17 GND Vcc 3 18 ALC NC Nor/CrO2 2 19 R158 220 2 11.6V Q12 KTC320 0V 0V R168 12 L104 330µH G L C111 330P 1 20 NC 0V 0.7V Q121 0V KTC3199 GR MUTING C151 0.027(ML) 0V 0V 0V R105 3.3K 112K Hich=T1 + 112K – R153 10K Q124 2SA1015 GR L103 SWITCHING C150 R166 R167 R160 0.0039 47K 100K 150 (1/2W) 100µH 11.7V C105 180P 21 – + R157 220K Q122 KTC3199 GR C129 470P C131 R139 0.001 560 R141 C135 56 0.082 C139 0.0033 Q105 0V KTC3200 GR 0.7V 22 REC_L REC_R C134 22/25 R137 6.8K 0V R106 3.3K Q106 KTC3200 GR 0V 23 0V R135 18K 0V 0.7V R156 220K 0V MUTING R154 0.7V 10K C128 3.3/50 0V 0V R131 33K 0.7V R C112 330P 24 R121 100K R123 3.9K R108 47K R104 2.2K C117 0.033 R-CH L-CH 0V C108 0.001 C106 180P 1 2 3 4 5 6 7 CNP102 TAPE2 RECORD/ PLAYBACK HEAD R126 5.6K R124 3.9K C116 R118 C114 47/25 C122 1K 330P 1/50 Q108 KTC3199 GR SWITCHING C101 0.001 R132 33K C120 560P C118 0.033 R122 100K R101 1K C107 0.001 CNS102 1 M_GND 2 ERASE 3 T2_R2 4 A_GND 5 T2_R1 6 T2_L1 7 T2_L2 R120 56 R102 1K R110 4.7K ERASE HEAD C102 0.001 Q107 KTC3199 GR SWITCHING CNP101 2 R109 4.7K TAPE1 PLAYBACK HEAD CNS101 1 T1_R 1 2 A_GND 2 3 T1_L 3 9.3V Q104 KTC3200 GR L-CH R-CH MECHA BASE 0V Q109 2SA1318 SWITCHING R172 220K R134 68K 1 3.4V 3 Q111 KRC104 M SWITCHING R112 10K 8.6V R171 220K R170 1.8K 0V 9.3V E 3 1 R115 4.7K R R173 Q113 KTC3199 GR 5.6K C603 4.7/50 C604 4.7/50 Q114 KTC3199 GR R174 5.6K D102 1SS133 0V 2 R113 10K L +B 3.4V R169 1.8K D101 1SS133 R114 10K C153 100/16 C109 0.047 CHASSIS Q110 KRC104 M SWITCHING +B C155 3.3/50 C103 0.01 R175 1K C127 0.022 D F R609 2.2K C624 0.001 R618 2.2K Q602 KTC3199 GR R614 10K R652 100K C625 0.001 Q601 C621 KTC3199 GR R617 10/50 2.2K C623 0.001 C602 4.7/50 20 ZD602 MTZJ2.4B C R619 2.2K C627 22/25 CNS901 L_CH A_GND 1 2 3 4 5 6 7 8 9 R616 4.7K R636 330 Q604 Q603 KTC3199 GR KTC3199 GR R615 4.7K R635 330 R611 330 R613 10K C635 8200P C615 0.22 C605 4.7/50 B 1 2 3 4 5 6 7 8 9 R601 1.5K R603 1.5K R605 1.5K R607 1.5K C611 0.033 C613 0.22 CD-C662 BI99 R639 @22K JK601 R651 1K R650 1K C632 390P R631 8.2K C631 390P R642 47K R574 330 –B D556 1SS133 4 1 R573 560K R157 220K R578 100K C568 2.2/50 DI CE DO CLK HP-R CH HP_RLY HP_GND ZD551 MTZJ6.2C 0V 0.7V Q121 0V TC3199 GR MUTING HP-L CH SPEANA1 SPEANA2 SPEANA3 NC M_+12V NC SP_DET SPN_P NC SP_RLY HI_CUT S_MUTE T_T1 T2 T_BIAS REC/PLAY C145 22/25 C146 220/16 +B +B A_GND BI11 CD_GND C859 0.1(ML) 1 2 3 4 5 6 C860 47/25 +B R851 33 R850 3.3(1/2W) Q851 KIA7812P 3 1 2 C856 0.1(ML) Q852 KIA7806P 3 1 2 D850 1SS133 D851 1SS133 R855 3.3 (1/2W) C855 0.1(ML) 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 CNP701 +B 1 1 GND 2 2 +5V 3 3 +B BI801 CNS801 +B C858 0.1(ML) C641 0.001 C851 22/25 C853 0.047(ML) TUN_SM SUR_ON/OFF D_GND +5V +B Q850 KTD2058Y C857 47/25 A_+12V R853 22K M_GND R854 10K 0V R168 12 +B R-CH A_GND L-CH CD_GND +7V +12V 0V BIAS OCS 0V 3 2 C854 47/25 0V Q126 KRC104 M Q128 BIAS KTC3203 Y D853 1SS133 11.6V 1 R852 22K 3 C852 0.047(ML) +B 1 0V 2 +B Q853 AN78L05 D852 1SS133 11.6V R162 47K M_+12V C152 47/25 5 K R164 4.7K 12 C151 0.027(ML) GND Vcc 11 0V L104 330µH 13 Q124 2SA1015 GR L103 SWITCHING C150 R166 R167 R160 0.0039 47K 100K 150 (1/2W) 100µH 11.7V 14 ALC RIPPLE R158 220 24 23 CNS701 8 7 R579 100K IC563 KIA4558P OPE AMP. OPE AMP. REC_L C566 2.2/50 D555 1SS133 8 7 2 R555 C556 3 56K 0.0068 C561 R572 R560 0.022 2.2M 470K 5 SPA SIG R567 6 R561 C562 270K 15K 0.022 +B D554 1SS133 IC562 KIA4558P R566 2.2M 4 5 8 7 6 9 1 R580 100K C555 0.0068 D551 1SS133 4 1 C567 2.2/50 +B –B C563 0.022 +B C553 0.0027 –B R564 390K R551 10K R575 330 C551 R562 270P 390K R568 2 220K R556 C557 3 270P 33K R570 220K C559 R558 5 68K 0.0027 6 R553 12K R637 220K 3 +B –15V –B CHASIS 2 3 1 2 3 4 5 6 CNS11 CNP11 P25 12 - B TO POWER SUPPLY PWB 7 8 9 10 Figure 19 SCHEMATIC DIAGRAM (2/10) – 19 – 11 12 P20 1 - D TO DISPLAY PWB +12V +B TUN_L DO CE DI CLK D_GND A_+12V C569 0.022 R638 220K EC_R R-CH D601 1SS133 D602 1SS133 C630 0.001 TUN_R A_GND R626 2.2K C628 0.22 R624 330 L-CH VIDEO/AUX IN R633 39K C850 3300/25 @4.7/50 R634 39K CNP801 P23 7 - F TO POWER SUPPLY PWB R641 22K R632 8.2K P26 5 - A TO TUNER SECTION R640 47K 3 2 1 IC99 DIGITAL OUTPUT PWB-A4 D_OUT 1 C99 C98 3 3 100/10 0.022 +4.3V 2 2 L99 1 1 2.2µH CNS99 CD GND P25 12 - D CNP99 TO CD SERVO PWB CD-C662 DISPLAY PWB-A2 F2 F2 F2 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12 S11 S10 S09 S08 S07 S06 S05 S04 S03 S02 S01 G11 G10 G09 G08 G07 G06 G05 FL701 A R722 100K R723 100K 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 80 79 78 +B 80 S10 79 VLOAD 76 S13 78 S11 74 S15 IC701 CD IX0301AW SYSTEM CONTROL MICROCOMPUTER 73 S16 72 S17 71 S18 CNS701 DI CE 23 DO 22 CLK 21 HP-R CH 20 HP_RLY 19 HP_GND 18 HP-L CH 70 S19/DIST1 69 S20/DIST2 24 CD 65 SPN_P 53 T-BIAS 64 SP-DET 52 REC/PLAY 63 SP_RLY 51 AC RLY-CON CD 62 POWER 61 HI-CUT CD C 60 NC H:ECHO START L:DEMO START 28 SPEAN 29 TUN SM 30 T2 RUN 54 T_T1T2 53 52 51 1K 10K +B +B +B R752 10K R753 10K +B +B R760 10K +B Q702 KTA1273 Y 12V 0V 12V Q703 KTA1271 Y FWM1 2 + _ MM1 TAPE MOTOR 1 CNPM1 M G PHM1 RUN PALS SENSOR SWM3 F.P. CNPM2 SWM4 F.A.S SOLM1 SOLENOID SWM5 CAM FWM2 R758 1.2K CNSM1 1 2 3 4 5 6 7 8 9 1 2 3 4 5 6 7 8 9 10 11 12 10 11 12 1 2 3 4 5 6 7 8 MOTOR GND +12V T2 RUN FPA T1 RUN SOLENOID CAM SW R759 10K 12V 12V 0V C705 47/16 D716 1SS133 +B BI702 TAPE MECHANISM PWB-F H • NOTES ON SCHEMATIC DIAGRAM can be found on page 13. 1 2 3 4 Figure 20 SCHEMATIC DIAGRAM (3/10) – 20 – 5 +B R755 10K R756 10K R R754 10K F R750 10K R748 10K LED722 R747 SLI342UCJ 10K +B +B R741 1K 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 R738 R739 R740 1K +B D714 D715 1SS133 1SS133 22K 1K 1K 1K 57 KEY JOG B 56 KEY JOG A 55 DIST0 R749 10K D_GND +5V R712 R713 R714 R715 DIST0 58 S MUTE 2.2K 2.2K 1.8K 1K 1K JOG701 VOLUME JOG B A 1K 1K 1K R733 R734 R735 R736 R737 HI_CUT S.MUTE T_T1 T2 T_BIAS REC/PLAY TUN SM R709 R710 R711 1K 1K 1K +B 59 NC R730 R731 R732 E 1K R729 10K 9 8 7 6 5 4 3 2 1 R705 R728 10K 11 10 1K 1K 1K C704 0.001 12 R701 R702 R703 JK671 HEADPHONES C703 0.001 13 66 DISTOUT +B 10K 10K 10K P19 12 - E TO MAIN PWB CNP701 14 R724 R726 R727 15 10K 10K 10K 16 D SPEANA1 SPEANA2 SPEANA3 M_+12V SP_DET SPN_P SP_RLY 67 S22/DIST4 C673 0.01 R717 R719 R720 17 68 S21/DIST3 D703 1SS133 H/P FPA T1FAS CAM SW VDD T_MOT T_SOL FFC701 1 VDD 2 NC 3 DO 75 S14 R716 33 C 77 S12 TIMER LED U/D SW DNO SW VSS REMOCON SYS STOP O/C SW PUIN SW AVREF R706 1K R707 1K R708 1K C702 1/50 C720 47/50 S9 S8 S7 S6 S5 S4 S3 S2 S1 G11 G10 G9 G8 G7 G6 G5 R721 100K Q707 KTC3199 GR Q705 KTC3199 GR B Q706 KTC3199 GR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 6 CD-C662 F1 F1 F1 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 RWC(DSP) WRQ(DSP) CO IN(DSP) SQ OUT(DSP) CQ CK(DSP) RES(DSP) DRF(ASP) D_GND SLD+ SLD– PUIN SW OPEN/CLOSE DISC NO UP/DOWN PCCL S05 S04 S03 S02 S01 G11 G10 G09 G08 G07 G06 G05 G04 G03 G02 G01 P25 7 - G TO CD SERVO PWB CNP12 CNS12 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 BI12 C706 1/50 C709 +B 0.022 R773 R772 R771 10 XL701 11 4.19MHz 12 NC NC 0.022 47/25 C717 C716 TUNER (BAND) RD15 3.3K VIDEO/ AUX SW710 SW711 SW712 SW713 SW714 SW715 RD01 820 RD02 1.2K RD03 1.5K RD04 1.8K 6 6 SW701 RD05 2.2K RD06 3.3K RD07 3.9K SW705 SW706 SW707 SW703 SW704 TIMER/ SLEEP CLOCK DISC1 DISC2 7 8 9 DISC3 RD09 6.8K SW708 SW709 DISC SKIP OPEN /CLOSE 1 Q6 Q5 RIDER RIDER RIDER RIDER RS701~RS705:1K LED704,LED705:SLI342UCB NIGHT NIGHT NIGHT NIGHT FW703 1 NIGHT RIDER 6 LED706 SLI342YCB LED707 L1154GT4 NIGHT RIDER 7 NC NC NC NC 1 2 3 4 5 6 7 8 9 CD TAPE SW716 SW717 1 2 3 4 POWER RD16 3.9K RS705 STOP RD14 2.2K 18 17 16 15 14 13 12 11 10 LED704 LED705 REC MEMORY/ PAUSE SET RD13 1.8K EQUALIZER DIMMER 10 Figure 21 SCHEMATIC DIAGRAM (4/10) – 21 – 11 12 NIGHT RIDER 5 RD12 1.5K NC SW728 SW729 SW730 X-BASS/ DEMO PLAY IC703 BU2092F INPUT/OUTPUT EXPANDER RS702 RS703 RS704 REW RD11 1.2K +B LED702 SLI342YCB LED703 SLI342DCB RD10 820 TUNING DOWN TUNING UP CNP704 P23 7 - G TO POWER SUPPLY PWB BI704 FF RD28 6.8K VSS VDD DATA OE CLOCK Q11 LCK Q10 SW722 SW723 SW724 SW725 RD27 3.9K Q9 Q8 Q7 RD26 3.3K C719 0.022 RD24 RD25 2.2K 1.8K C718 47/25 RD23 1.5K RS712 1.2K RD22 1.2K D720 1SS133 RS711 1.5K 1 2 3 C714 0.022 RD21 820 +B SWITCH PWB-A3 +B R798 100 REMOTE D719 +B SENSOR 1SS133 RX701 N63H380A C722 10/50 C713 0.022 C711 0.01 C723 0.1/50 1 R797 100K R757 10K R754 10K D718 1SS133 D717 1SS133 +B +B +B R799 4.7K 5V BACK UP IC704 D705 KIA7042AP 1SS133 1 RESET 3 Q704 KRC102 M C712 3.3/50 2 2 3 3 AC_RLY CON 2 UN_SW 5V 1 D_GND C715 47/16 R744 1K R743 1K R745 1K L702 100µH R795 47K R755 10K R756 10K CNS704 6 VF2 5 –VP 4 VF1 6 5 4 3 2 1 +B R751 3.3K R741 1K R750 10K R738 R739 R740 1K R749 10K R748 10K R752 10K R753 10K R742 1K 1K 10K 2.2K 2.2K 1.8K 1K 1K R733 R734 R735 R736 R737 LED722 R747 SLI342UCJ 10K B +B NC 29 30 +B LED716,LED717, LED721,LED723,LED724:SLI342YCJ LED718:SLI325YC LED719,LED20:SLI342YCE RS706 1K 27 28 RS707 1K 26 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 +B NC NC 10 11 12 13 14 15 16 17 18 25 Q0 Q1 Q2 Q3 Q4 23 RS701 22 24 9 8 7 6 5 4 3 2 1 LED701 L1154GT4 21 NC 20 IC702 BU2092F INPUT/OUTPUT EXPANDER +B LED718 LED719 LED720 LED721 VDD T_MOT T_SOL ST0 19 1K 1K 1K 1K 1K 1K 1K 1K Q4 Q5 Q3 Q6 Q2 Q7 Q1 Q8 Q0 Q9 Q10 LCK Q11 CLOCK OE DATA VDD VSS 18 TIMER LED U/D SW DNO SW VSS REMOCON SYS STOP O/C SW PUIN SW AVREF AVDD KEYIN1 KEYIN2 KEYIN3 17 51 AC RLY-CON 1K R769 R768 R767 R766 R765 R764 R763 R762 1K 1K 1K 1K 1K 1K PCCL CD DSP COIN SQOUT CD DSP CQCK CD DSP RES FRF(DRF) H:ECHO START SPEANA1 28 SLD+ L:DEMO START 29 TUN SM SLD– 30 T2 RUN AVSS SPEANA3 SPEANA2 52 REC/PLAY R770 LED716 LED717 53 T-BIAS C708 18P 13 14 CD DSP WRQ 15 VDD 16 R787 R786 R785 R784 R783 R782 DSP RWC RESET X2 X1 VPP XT2 +B STOP PLAY CD TUNER TAPE VIDEO IC701 CD IX0301AW SYSTEM CONTROL MICROCOMPUTER R780 10K +B C710 220/10 1K 1K 1K 1K 1K 1K 1K 1K C707 15P R781 820 78 S11 DI CE CLK LCK1 LCK2 R778 R777 R776 R775 R774 LED723 1 VDD 2 NC 3 DO 80 S10 79 VLOAD 1 2 3 4 5 6 7 8 9 LED724 S5 S4 S3 S2 S1 G11 G10 G9 G8 G7 G6 G5 G4 G3 G2 G1 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 16 15 14 13 12 11 10 9 7 VH+ 8 VL+ VL– 17 6 5 4 3 C925 47/50 Q904 KTC3199 GR R915 3.9K D905 1N5402M ZD902 MTZJ8.2C D904 1SS133 R916 3.9K R961 39K R919 1.5K Q901 KTC3199 GR D907 1SS133 R921 4.7K C918 R911 2.2/50 33K Q911 Q910 KRC107 M KRC107 M R959 8.2K C955 22/25 R956 1K R957 100K 2 3 D913 1SS133 1 3 R962 39K D910 1SS133 1 C904 4700/35 VL– –B R913 100(1/4W) Fusible R958 680 R928 10(1/2W) R926 10(1/2W) C901 3300/71 2 R960 10K Q909 KTC3199 GR C924 0.022(ML) R920 1.5K R918 0.1(3W) C903 4700/35 R955 1K D908 1SS133 R922 4.7K C902 3300/71 VH– SP DET D902 1N4004S –B C952 220/25 C951 0.022 (ML) D901 1N4004S C920 100/100 C957 47/100 VL+ Q902 KTC3199 GR Q908 KTC3199 GR R954 3.3K –B D906 1N5402M B C922 47/50 C956 47/100 C923 0.022(ML) Q903 D909 1SS133 KTC3199 GR D903 1SS133 ZD901 MTZJ8.2C R912 100(1/4W) Fusible R906 1K R910 56K C 1 R917 0.1(3W) C919 100/100 C912 47P R953 3.3K 2 VH+ R902 1K C921 47/50 C917 2.2/50 R909 56K 18 R901 1K 19 R903 56K C915 47/50 C911 47P R905 1K 21 20 C913 33P C914 33P 22 R907 390 R908 C916 R904 390 47/50 56K A IC901 STK4113E POWER AMP. + – + – VH– CD-C662 –B R943 ZD951 MTZJ13B 680(2W) D PO +B +B E 5 6 VL+ BI802 7 8 VH+ 4 CNP802 CNS901 P18 1 - C TO MAIN PWB 3 GND 2 VH– 1 VL– CNP901 HP_RLY HP_GND GND 9 10 11 12 13 HP-R-CH R-CH 7 8 SP_DET A_GND 6 5 HP-L-CH 4 M_GND 3 M_+12V 2 –15V SP_RLY 1 L-CH +B CNS802 F VH+ 8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 P19 12 - G CNS801 1 TO MAIN PWB 3 2 VL+ GND VL– VH– CNP80 +B GND +5V CNP70 6 P21 12 - E CNS704 TO DISPLAY PWB 5 4 3 2 G 1 H • NOTES ON SCHEMATIC DIAGRAM can be found on page 13. 1 2 3 4 Figure 22 SCHEMATIC DIAGRAM (5/10) – 22 – 5 6 CD-C662 POWER AMP.PWB-B2 VH+ RL901 L901 0.29µH Q903 D909 1SS133 KTC3199 GR L-CH 6ohms R-CH Q905 KRC107 M D911 1SS133 R931 4.7(1/2W) R923 56K C925 47/50 C929 0.1(ML) R929 56K R927 10(1/2W) Q904 KTC3199 GR D905 1N5402M + – – + R925 10(1/2W) SO901 SPEAKER TERMINAL 2 1 R934 4.7K C930 0.1(ML) R930 56K R935 220(1/2W) +B 3 R928 10(1/2W) R926 10(1/2W) R933 4.7K L902 0.29µH 1 C903 4700/35 D901 1N4004S C943 10/50 2 C945 47/25 R936 220(1/2W) D912 1SS133 R937 15K R942 560 (2W) CNP903 R939 3.9K R938 68K CNS903 + 1 2 – M M903 FAN MOTOR Q907 KTC3199 GR R932 4.7(1/2W) R941 560(2W) POWER SUPPLY PWB-B1 +B BI802 T801 POWER TRANSFORMER ~ 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 D809 TS6B04GM – ~ VH+ F804 5A/125V C811 0.22(ML) VL+ GND 1 C813 0.047 (ML) C816 100/50 C815 100/50 T.F D817 1N4004S Q803 KTA1274 Y VOLTAGE REGULATOR +B C801 0.0047 D_GND D807 1SS133 +B D801 1SS133 R804 1K D808 1SS133 Q802 KTC3199 GR 8 C805 2200/6.3 +B 7 C817 220/50 R802 2.2K UN_SW_5V F801 5A/125V F806 2A/250V 9 Q801 AN78L05 1 D804 1N4004S C802 0.047 (ML) D802 1N4004S T802 POWER TRANSFORMER 3 2 C803 470/25 2 R805 ZD802 MTZJ6.2A 10 VF1 AC_RLY_CON D806 1SS133 3 L802 –VP 100µH R801 100 TO DISPLAY PWB 4 CNP704 VF2 C804 10/16 P21 12 - E CNS704 5 ZD801 MTZJ30C +B R803 12K 6 D812 1N4004S GND +5V C818 47/50 3 2 C819 47/50 TO MAIN PWB CNP801 +B D811 1N4004S C814 0.047 (ML) VH– D816 1N4004S –B D813 1N4004S D815 1N4004S VL– C820 100/35 1 F805 5A/125V C810 0.22 D814 1N4004S P19 12 - G CNS801 C809 0.22 C812 0.22 (ML) 8 + CNP802 CNS802 D810 BR102J02 RL801 7 8 VH+ 6 AC POWER SUPPLY CORD (249) AC 120V/60Hz D805 D803 1N4004S 1N4004S 10 Figure 23 SCHEMATIC DIAGRAM (6/10) – 23 – 11 12 CD-C662 + VCR + IC1 LA9241M SERVO AMP. R29 56K R45 4.7K C29 4.7/50 CL CLK DEF CE DAT SLOF SL– R43 56K R38 470 HF TP1 C23 0.0027 40 39 38 6 C22 220P R36 220K R33 R32 1.2K 10K C21 0.0033 SPO SPG R28 10K C16 0.0047 C13 330P REF FE1 REF AGND SP REF SPI FA– R23 10K C20 47/16 NC C18 0.47/50 C12 0.1 42 37 TES 36 TOFF 35 TGL 34 JP+ 33 SLD 29 30 31 32 R34 3.3K VREF R42 47K C25 R39 27P 1K R40 5.6K C19 1/50 S.Q.R REF – FE– C10 180P REF – R19 1K R41 47K 43 41 R44 33K C26 0.033 HFL – – – R27 R31 39K 1.2K R25 1.5K C17 0.001 R30 6.8K SLOF 5 – – R21 R20 1.5K 1K 44 C24 2.2P – R24 47K 1 R26 82K C14 0.01 CV+ CV– + C11 R18 0.1 15K REF SLEO SP– 24 25 26 27 28 FD– FA FE 17 18 19 20 21 22 23 4 JP+ JPCLO SLOF SLOF OR 10 + RFSM RF SL+ JP– – – REF + CV+ JP– – REF + + JP FSC REF FOSTA TO GEN REF + GEN REF + FSTA REF JP – REF SLC – CV– + + REF – R22 820 3 RFS– + TD R17 33K 8/12CM + + FO– TR– ACTUATOR GEN 45 + D TGL1 + FO+ TD– SLI CL VCC THDL GL + TR+ TR– TR+ FO+ FO– GND PD VR LD REF THD 14 JP TO + 15 FD 16 8 REF SLOF + 1 2 3 4 5 6 7 8 13 FSTA + – LT0H30M1 K E A B F 11 LASER 46 DGND 2FREQ REF C7 0.1/50 TH 10 C8 0.068 12 FSC CE C28 0.1 C27 0.001 – VCR EFBAL FOSTA TOSTA – 5 4 3 2 1 A F C R15 R14 12K 27K R16 3.3K DRF NC 48 TBC 47 LATOH + VCR + LD MON K E B LD GND FSS DRF HFL – R10 C5 2.2K 0.033 8 TESI C6 0.033 9 SCI R12 100 R13 C9 1K 0.047 VCC2 – VCR REF – REF R11 6.8K REF1 DEF REF + + + FE1 7 C54 0.001 VR LF2 PHI BHI LDO VCC1 + + – REF – 6 TE– TE 55 54 53 52 51 50 49 REF 5 TB R8 15K 56 2 + R9 100K 57 – C4 0.1/50 TE C C30 0.1/50 C31 220/6.3 R46 560 C2 0.01 3 4 F 58 – CNS1A 59 – CNS1B 61 60 RF – 1 2 3 4 5 CNP1 – 1 FIN2 REF – 2 FIN1 EREF – – 1 2 3 4 5 64 63 62 LDS 9 K A B E F + B 5 4 3 2 1 + K E A B F R1 22 C3 1/50 C33 0.47/50 C32 0.01 C1 47/16 Q1 2SA1318 C15 0.01 C34 0.33/50 R2 1K A 7 R35 220K C57 0.001 GND C35 1/50 PICKUP UNIT TR– TR+ FO+ FO– M2 SLED MOTOR SW4 PICKUP IN M M – + – 6 5 4 3 2 1 6 5 4 3 2 1 FO (GAIN) FO+ FO– TR+ TR– 12 14 15 SL– 16 SL+ M– 38 SOL– 37 SOL+ 36 35 GND 32 31 30 R56 22K +B C82 100/16 C77 100/16 +B 29 VCC3 28 +B SP+ 27 SP– 26 21 MUTE +B 34 33 SPO 25 20 Vref +B M+ 39 18 VCC1 C55 100/16 +B VCC4 40 17 SLD 19 STANDBY CNP3 6 5 4 3 2 1 LD_M– 41 13 CD_GND 6 5 4 3 2 1 CNS3A CNS3B CNP3A + LD_M+ 42 FD 10 11 GND C36 100/16 M1 SPINDLE MOTOR TO (SPN)VCC2 24 SOLD 23 SOL– 22 +B +B SP+ SP– SL_+ SL_– CD_PUIN RWC(DSP) WRQ(DSP) CO IN(DSP) SQ OUT(DSP) CQ CK(DSP) R47 10K RES(DSP) DRF(ASP) D_GND C37 0.022 SLD+ SLD– PD C76 0.022 CNS2B CNS2A TR– 1 1 1 TR+ 2 2 2 FO+ 3 3 3 FO– 4 4 4 GND 5 5 5 PD 6 6 6 VR 7 7 7 LD 8 8 8 LD CNP2 CD MOTOR PWB-D G 1 2 3 4 5 6 7 8 9 IC3 M63001FP FOCUS/TRACKING/SPIN /SLED DRIVER E F D1 +B 1SS133 R37 82K CNP12 1 2 3 4 5 6 7 8 9 10 CNS12 P21 10 - A TO DISPLAY P H • NOTES ON SCHEMATIC DIAGRAM can be found on page 13. 1 2 3 4 Figure 24 SCHEMATIC DIAGRAM (7/10) – 24 – 5 6 CD-C662 R57 1K R58 1K R59 1K C49 100P(CH) C48 100P C47 100P(CH) C44 100P(CH) C46 100P (CH) R60 1K C38 0.01 C45 100P(CH) CD SIGNAL R61 1K R62 1K R63 1K +B +B +B R66 220 R64 22 C75 0.001 +5V 32 CD_LCH P19 8 - H CNS11 TO MAIN PWB Q52 KTC3203 Y R55 +B C43 100 330/6.3 R65 1K L61 0.82µH +B C50 0.022 1 2 3 4 5 6 L-CH D-GND +7V +12V A_GND C73 220P C52 100/16 DOUT C74 220P R74 100K R71 C71 R73 2.7K 10/50 100K DIGITAL OUT R-CH A_GND CD_RCH ZD61 MTZJ5.6B R72 2.7K RVSS 39 TEST4 33 24 25 26 27 28 29 30 31 D82 1SS133 C72 10/50 34 CONT5 NC EMPH NC C2F NC CONT4 EXTERNAL OUTPUT CNP11 R93 220 44 LVSS 38 LCHO 37 LVDD 36 MUTEL NC 35 IC2 LC78622NE SERVO/SIGNAL CONTROL 17 18 19 20 21 22 23 45 C51 100/16 XOUT SYNC-DETECT EFM DEMODULATE PCK NC FSEQ NC VDD JP_ JP+ EFMIN 11 C42 15P XL1 16.934 MHz D81 1SS133 SBCK SFSY NC WRQ RWC FSX NC COIN SQOUT 4FS DIGITAL FILTER VSS EFMO TOFF TGL C22 220P /CQCK VVDD FR SLICE LEVEL CONTROL TEST2 11 CLV+ CLV 12 CLV_ DIGITAL 13 SERVO V/P 14 HLF 15 SERVO TES COMMAND 16 10 XVSS 46 XVDD 43 MUTER NC 42 RVDD 41 RCHO 40 ERROR COERECT FLAG CONTROL CONT3 R53 1.2K 2KX8 RAM CONT2 6 7 8 9 X-TAL GENERATOR 1BIT @DAC 4 VVSS 5 ISET C40 0.047 R52 27K C41 12P TEST3 NC 3 PDO C39 R50 0.047 680 EFLG NC 48 SBSY 47 NC XIN CONT1 2 K SUB-CODE µ-COM INTERFACE C83 0.022 1 2 TA1 R51 3.3M VCO CLOCK OSC CONTROL 4 K 16M NC TEST11 NC /RES /CS TEST5 4M TEST1 DEF1 PW NC 49 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 +B R88 1.2K R89 1.2K R90 220 R91 1K +B +B R54 330 C56 0.022 +B BI1A 2 1 2 1 +B BI1B CNP99 +B C57 0.001 +B P19 10 - A CNS99 TO DIGITAL OUTPUT PWB 3 2 1 +B 133 +B +B R80 820 R83 390 D92 1SS133 R82 390 2 CD SERVO PWB-C R81 820 3 D93 1SS133 1 SOLM2 SOLENOID R84 2.2K LOCK D91 1SS133 Q51 KRC102 M BIM05 1 2 3 4 5 6 1 SOL+ 2 SOL– 3 M– M+ 4 GND(D) 5 DISC NO. 6 OPEN CLOSE 7 GND(D) 8 MECHA UP 9 10 10 GND(D) CNP10 CNS10 1 2 3 4 5 CD_D_NO 6 7 8 9 – M + M3 T/T UP/DOWN LOADING SW1 OPEN CLOSE SENSOR PWB-E SW2 MECHA UP 1 2 PCCL PUIN SW CO IN(DSP) SQ OUT(DSP) CQ CK(DSP) R47 10K RES(DSP) DRF(ASP) D_GND C37 0.022 SLD+ SLD– M– M+ 1 2 DISC NO SW3 DISC NUMBER CNS5 OP/CLOS DISC NO. UP/DOWN 2 3 4 5 6 7 8 9 10 11 12 13 14 15 CNS12 P21 10 - A TO DISPLAY PWB • The numbers 1 to 12 are waveform numbers shown in page 14. 7 8 9 10 Figure 25 SCHEMATIC DIAGRAM (8/10) – 25 – 11 12 H 1 1 2 3 1 2 3 CNP301 1 G 3 5 C313 0.022 6 2 D301 C305 15P(CH) VD302 SVC211C R301 33K R303 100K L302 FM RF C309 4.7P (UJ) 1SS133 3 7 8 PD CL 5 A IN DI 4 BO4 X OUT X352 4.5MHz VSS C312 0.001 C311 0.022 C308 0.0047 Figure 26 SCHEMATIC DIAGRAM (9/10) – 26 – 4 9 10 11 IO1 IO2 A OUT CE 6 AM IN FM IN BO1 VDD DO 3 IF IN D305 1SS133 R379 2.2K X IN 1 2 +B 1 3 0.2V 2 10.9V +B L343 100µH 1 R369 2.2K 3 R366 820 C382 15P (CH) C333 0.022 ZD351 MTZJ5.1B +B C365 1/50 22 21 20 19 18 17 16 15 14 13 12 R381 10K C383 0.022 C369 47/16 2 AM IF R367 820 D304 1SS133 C393 1/50 R380 1.5K C338 100P CF351 9 10 C366 1/50 C381 12P(CH) C320 0.001 +B C334 22P (UJ) C392 0.001 C316 100P Q302 2SC535 C OSC BUFF C360 0.022 R313 47 0V 4.4V AM MIX 15 14 C364 0.015 T351 C361 22/16 7 8 C363 TUN 0.015 IND ST IND GND AM IF 5 6 MPX L CH -IN C359 0.022 +B FM DET 4 R CH 3 16 R359 47K 11 8.4V D342 1SS133 R365 680 R361 10K FM/AM SWITCHING Q343 KRA109 M 3 1 5.1V 12 VR351 6.8K(B) VCO C358 0.0015 R352 15K R350 47K R375 1.2K 13 C367 1/50 2 4.4V AM /FM 0.7V R323 68K R312 680 R317 820 FM +B AM RF AM +B AM OSC 2 17 R360 1.5K IC303 LA1805 FM/AM IF MPX. C353 0.018 FM IF IN 1 18 DET OUT 2 C332 0.022 TP301 20 19 R347 3.9K FM DET. C349 0.022 24 23 22 21 R348 33K C354 220P FM– M/ST R316 4.7K R314 C318 10K 22P(CH) VD303 CF301 SVC211C 3 C330 8.2P(UJ) C331 0.047 C335 560P AM OSC. R321 120 T352 C355 3.3/50 R311 220K 1 R320 10K VD331 SVC348S T333 +B +B R371 1K R372 1K R373 1K R374 1K 5 D_GND CE DI CLK DO TUN_L A_GND TUN_R A_+12V C395 0.001 R362 390 AM SIGNAL C314 10/16 C319 0.022 L303 +B C337 10/50 C306 C317 18P(CH) 3.9P(UJ) +B E C356 3.3/50 VCO FM SIGNAL 9 R306 10 C350 220/10 FM OSC. T301 FM IF 7 8 D C304 4.7P (CH) 4 TP302 C357 3.3/50 R302 22 3 +B C351 0.0022 C310 0.001 2 AM ANT. T331 C R305 C303 0.01 82 C302 1 10P(CH) IC301 TA7358AP FM FRONT END F 2 BF301 B MAIN PWB-A1(1/2) A FM ANT AM LOOP ANT 9 8 7 6 5 4 3 2 1 CHASSIS GND CD-C662 P19 12 - C TO MAIN/DECK SECTION R356 10K Q344 KRA102 M SWITCHING 11V IC302 LC72131 PLL(TUNER) C307 0.0047 D303 1SS133 D302 1SS133 • NOTES ON SCHEMATIC DIAGRAM can be found on page 13. 6 CD-C662 IC1 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 IC3 IC2 VOLTAGE 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 0V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.5V 2.3V 2.3V 0V 0V 5.0V 5.0V 0V 0V 5.0V 0V 0V 1.6V 2.4V 2.4V 2.4V 0V 2.5V 2.5V 0V 0V 2.4V 4.6V 4.6V 0V 0V 5.0V 5.0V 2.5V 2.5V 1.0V 1.0V 2.2V 4.2V 0V 5.0V 7 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 VOLTAGE 0V 0V 0V 0V 1.9V 5.0V 0V 0V 2.5V 2.4V 0V 0V 0V 5.0V 0V 0V 5.0V 5.0V 0V 0V 2.5V 0V 5.0V 0V 0V 0V 0V 0V 0V 5.0V 2.5V 0V 0V 0V 5.0V 4.6V 1.9V 0V 0V 1.9V 4.6V 5.0V 5.0V 2.1V 2.1V 0V 0.1V 2.3V 0V 2.5V 0V 2.5V 0V 0V 0V 4.6V 4.6V 4.7V 0V 2.3V 2.3V 0V 0V 0V 2.5V 2.6V 2.9V 3.3V 3.3V 3.3V 3.3V 0V 0V 0V 0V 0V 0V 0V 3.3V 3.3V 3.0V 7.2V 5.0V 2.5V 0V 0V 0V 7.2V 2.5V 3.3V 3.3V 11.2V 0V 0V 0V 0V 0V 0V 0V 5.3V 5.3V 3.3V 3.3V 7.2V 0.1V 0.1V 8 PIN NO. 1 2 3 4 5 6 7 8 9 VOLTAGE 0.9V (0V) 1.6V (0V) 5.8V (0.4V) 1.6V (0V) 0V (0V) 5.9V (0.4V) 5.2V (0.2V) 5.8V (0.3V) 5.9V (0.3V) IC562 PIN NO. 1 2 3 4 5 6 7 8 VOLTAGE 0.2V 0.2V 0.2V –7.7V 0V 0V 0V 6.3V IC563 PIN NO. 1 2 3 4 5 6 7 8 VOLTAGE 0V (0V) 0V (0V) 0.5V (0.5V) 4.3V (4.3V) 0V (0V) 1.2V (1.3V) 0V (0V) 0.6V (0.6V) 4.2V (4.2V) 4.1V (4.1V) 0V (0V) 0V (0V) 8.3V (8.3V) 4.8V (4.8V) 0V (0V) 4.1V (4.1V) 0.6V (0.6V) 0V (0V) 0.8V (0.8V) 0.8V (0.8V) 4.3V (4.3V) 0.5V (0.5V) 0V (0V) 0V (0V) PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VOLTAGE 0.1V 0.2V 0.1V –7.7V 0.1V 0.2V 0.1V 6.3V IC901 IC101 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 IC302 IC301 VOLTAGE PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VOLTAGE 56.0V 0V 24.4V 25.0V 15.9V –16.0V –24.9V –55.9V –24.3V –24.3V –24.3V 0V 4.2V 0V 0V –54.5V 54.6V –0.15V –0.15V –53.1V –0.15V –0.15V IC704 PIN NO. 1 2 3 9 VOLTAGE 5.0V 0V 5.0V VOLTAGE 2.6V (2.6V) 0V (0V) 0V (0V) 0V (0V) 4.4V (4.4V) 4.8V (4.8V) 0.2V (11.9V) 0V (0V) 0V (0V) 0V (0V) 5.2V (5.2V) 0V (0V) 0V (0V) 0V (0V) 0V (2.6V) 2.5V (0V) 5.2V (5.2V) 0.9V (0.9V) 0.9V (0.9V) 1.3V (1.1V) 0V (0V) 2.6V (2.6V) IC601 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 IC303 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 VOLTAGE 0V 0V 0V 0V –0.2V 0V 0V 0V 0V 2.6V 0.1V –2.6V 0V 0V 0V 0V 0V 0V 0V 0V VOLTAGE 1.6V (1.7V) 1.6V (1.7V) 7.0V (8.4V) 0.3V (0.6V) 1.6V (1.7V) 0V (0V) 5.2V (5.2V) 0V (0V) 2.2V (2.3V) 2.4V (2.5V) 6.3V (8.3V) 0.9V (0.9V) 1.1V (0V) 1.8V (1.7V) 0.9V (1.2V) 1.7V (1.7V) 1.5V (1.7V) 1.6V (1.6V) 0.4V (0.5V) 7.0V (8.4V) 7.0V (8.4V) 1.6V (1.7V) 1.6V (1.7V) 1.6V (1.7V) IC703 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 VOLTAGE 0V 0V 0.4V 0V 0.4V 0.4V 0.4V 0.4V 0.4V 0.4V 0.4V 9.6V 9.6V 9.6V 12.9V 10.9V 0V 5.0V IC702 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 VOLTAGE 0V 0V 0.4V 0V 0V 0V 0V 0V 0V 0.4V 0.4V 0.4V 9.6V 9.6V 9.6V 0V 0V 4.8V 10 Figure 27 SCHEMATIC DIAGRAM (10/10) – 27 – PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 IC701 PIN NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 VOLTAGE 4.8V 4.8V 4.8V 0V 0V 0V 0V 0V 0V 4.8V 2.3V 2.2V 0V 4.9V 0V 4.9V 0V 4.8V 0V 4.8V 4.8V 0V 0V 0V 0V 0V 0V 0V 0V 4.8V 5.1V 5.1V 5.1V 4.8V 5.0V 4.7V 0V 5.0V 5.0V 0V 4.7V 0V 3.8V 11.3V 11.3V 4.8V 4.7V 4.7V 4.7V 0V Q850 PIN NO. 1 2 3 VOLTAGE 11.3V 18.1V 11.9V 11 VOLTAGE 7.3V 1.3V 19.0V 4.8V 4.8V 0V 4.8V 0V 0V 0V 4.8V 4.9V 4.9V 0V 4.8V 4.8V 5.1V 5.1V –21.5V –20.0V –19.5V –21.3V –21.3V –21.3V –27.5V 0V –0.7V –20.7V –18.0V –23.3V 0V –28.7V –0.1V –20.4V –20.6V –0.1V –23.3V –18.5V –21.1V 0V –0.5V –20.5V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V –25.8V Q851 PIN NO. 1 2 3 Q852 PIN NO. 1 2 3 VOLTAGE VOLTAGE 11.9V 0V 19.1V Q853 PIN NO. 1 2 3 12 VOLTAGE 6.3V 1.2V 11.3V CD-C662 P31 7 - H TO DISPLAY PWB CNS701 A FFC701 1 R371 R379 C369 D342 R350 C366 23 R638 C601 C367 Q343 C350 R361 C363 C364 19 21 R366 3 2 1 D305 C358 D304 C602 R641 R640 R642 R639 R620 C626 R616 R619 R611 C621 R613 C617 ZD601 B C E C627 R635 R636 B C E R615 C629 C625 Q603 R617 C611 C613 C615 ZD602 C619 C618 R628 C623 Q604 C561 R567 R574 Q601 B C E E C B C624 4 C620 Q602 C634 5 C556 R560 3 D556 R572 6 R580 2 R623 R630 C568 7 R556 1 C616 R614 IC562 8 R578 R652 R626 R612 C555 R566 R573 R610 R555 C635 R608 R625 C612 C614 C628 R606 1 R601 2 R603 3 4 R605 5 6 R607 7 8 9 10 IC601 20 19 18 17 16 15 14 13 12 11 R604 R653 R375 C622 R602 C566 C569 C562 C563 17 C606 VR351 VCQ ZD551 D554 R551 D551 R558 11 13 15 R650 R352 C353 R348 C551 R562 R568 4 C557 7 9 R367 R561 3 R579 R570 C559 2 C567 5 D555 L343 C381 C382 L303 CF351 C365 24 R618 C333 IC563 C553 R564 7 6 R575 22 C604 R553 F 20 R624 1 16 18 C356 8 14 C357 R632 C631 C632 R634 E 12 R381 R-CH L-CH 10 R637 24 2322 21 20 19 1817 16 15 14 13 R347 R360 C355 TP302 5 6 R362 1 2 3 4 5 6 7 8 9 10 11 12 C354 R359 4 ZD351 CNP701 R372 R373 R374 C305 Q302 C306 C317 VD303 C360 C359 C361 R631 D602 IC302 3 8 22 2120 19 18 17 1615 14 13 12 C316 C392 1 2 3 C351 R633 C383 R380 T351 C337 T352 C630 D601 C320 1 2 1 2 3 4 5 6 7 8 9 10 11 IC303 C349 D X352 R311 R306 R312 C313 VD331 CF301 T333 C338 C330 C331 C335 1 2 3 R365 R369 R356 C393 R320 C JK601 VIDEO/AUX B C E Q344 3 2 1 R317 R313 C311 R314 R316 R303 C310 TP301 C332 T331 VD302 C312 C309 D301 C334 8 9 C318 T301 C308 R323 7 R302 C307 R321 5 6 R301 1 D302 1 FM ANTENNA D303 3 2 CNP301 3 2 3 4 C303 L302 AM LOOP ANTENNA C395 B 1 2 IC301 R305 BF301 3 2 1 C319 C304 C302 C314 MAIN PWB-A1 G CNS901 1 2 3 4 5 6 7 8 9 10 11 12 13 CNP901 P33 12 - E TO POWER AMP. PWB H 1 2 3 4 Figure 28 WIRING SIDE OF P.W.BOARD (1/8) – 28 – 5 6 CD-C662 P31 7 - H O DISPLAY PWB CNS701 24 P35 12 - E TO CD SERVO PWB CNP11 CNP701 1 2 3 4 5 6 7 9 R140 C132 C134 C140 R138 E C B R629 Q111 C117 C121 R121 C119 C127 R123 C128 C133 C139 R137 C129 R135 R169 B C E B C E R157 R174 R172 Q852 Q851 Q121 Q850 3 2 1 3 2 1 B C E RED OR ORANGE YL YELLOW GR GREEN Q113 R852 BLUE VL VIOLET GY GRAY WHITE BK BLACK PK PINK CNS801 3 WH GY RD Q853 C853 C854 D853 3 2 1 BI801 C851 D852 C855 BL R850 C852 C857 BROWN WH(W) R851 C859 C860 RD(R) R175 R158 R173 R854 D851 BR R139 R141 C135 C155 C145 R153 R613 R636 R131 B C E D850 C627 COLOR TABLE R125 C131 C154 R170 R853 Q124 R164 R115 C153 R109 R110 C113 CNS101 TO TAPE MECHANISM TAPE1 HEAD C111 R102 1 2 3 4 5 6 7 8 9 10 11 12 R146 C156 P34 4 - D C115 Q114 R154 TO TAPE MECHANISM TAPE2 HEAD R101 R145 C146 C142 Q122 C605 R156 3 2 1 R119 C141 C611 R134 C136 R611 B C E R142 C102 C107 IC101 R111 C130 C858 R619 C621 ZD602 C619 R615 C629 C625 C122 R609 C617 ZD601 R628 C635 R653 C E C108 E C B 24 23 22 21 20 19 18 17 16 15 14 13 R124 R136 C603 Q603 601 R132 C615 C613 IC601 C618 C620 1 3 P32 1 - G 2 CNP801 1 TO POWER SUPPLY PWB R855 L601 C850 D102 CNS901 C103 R625 R126 1 R601 2 R603 3 4 R605 5 6 R607 7 8 9 10 C101 E C B R107 R117 C112 C118 C120 R651 P34 5 - D CNS102 Q108 R120 R122 R162 R155 R639 B C E E C B R108 1 2 3 4 5 6 7 CNP101 R105 C151 B C E L104 R103 Q103 C150 B C E C106 B C E R112 Q106 1 2 3 R171 R642 L103 R160 Q107 R640 Q126 3 2 1 R168 R104 Q104 Q105 Q110 3 2 1 C109 R118 C601 C641 R641 B C E R106 BI11 B C E C105 CNP102 23 R113 R114 Q128 R167 1 24 19 21 C114 22 Q109 17 C116 20 C856 18 13 15 C152 14 16 CNS11 R166 12 1 2 3 4 5 6 11 6 10 RD WH WH WH WH WH 8 D101 4 5 6 7 8 9 10 11 12 13 CNP901 P33 12 - E POWER AMP. PWB 7 8 9 10 Figure 29 WIRING SIDE OF P.W.BOARD (2/8) – 29 – 11 12 CD-C662 SWITCH PWB-A3 A SW708 DISC SKIP 9 RS707 LED707 LED706 RS706 C719 LED705 RS703 LED704 RS704 L RS705 RD09 RS711 C718 SW709 OPEN/ CLOSE IC703 10 1 18 RS712 B DISPLAY PWB-A2 36 35 34 33 32 31 30 29 28 27 26 39 38 37 R795 25 24 23 22 21 20 19 18 R721 C711 D705 RD28 C713 SW729 EQUALIZER R722 R771 65 5 10 IC701 60 5 45 C709 20 25 35 40 30 R762 SW728 X-BASS/DEMO R763 R741 XL701 31 R744 R757 R743 R773 R772 R776 R778 C707 R764 C723 SW722 FF R775 C708 L702 RD27 70 95 15 R774 E C B Q705 E C B 90 100 1 R777 D Q707 D720 C710 C722 1 2 3 IC704 E C B Q706 D717 80 85 75 R708 R706 C720 C712 R799 81 R707 1 2 3 R716 C706 R797 D718 SW730 DIMMER Q704 C C702 R723 D719 R75 C717 RD21 1 R760 C705 R728 15 1 D715 Q703 R724 BI12 E C B D716 R729 D714 B C E Q702 R758 R759 C703 C704 JOG701 VOLUME JOG 1 SW725 PLAY RD23 LED723 F 10 LED717 LED716 9 SW724 TUNING DOWN RD24 LED724 BI704 R781 SW713 STOP R786 RD22 R749 6 18 IC702 SW723 TUNING UP R787 R765 R768 R766 RD25 R770 RD26 R767 E R769 C716 BI702 8 1 CNS704 1 2 3 4 5 6 H 1 1 RD BL BL BL BL BL BL BL BL BL BL BL BL BL BL GR WH WH WH WH WH G CNS12 CNSM1 12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 CNP704 CNP12 CNPM1 P32 1 - F TO POWER SUPPLY PWB P34 12 - B TO CD SERVO PWB P34 6 - A TO TAPE MECHANISM PWB 2 3 4 Figure 30 WIRING SIDE OF P.W.BOARD (3/8) – 30 – 5 CNP701 P28 6 - A TO MAIN PW 6 CD-C662 RS703 LED703 LED702 SW707 DISC3 LED701 SW706 DISC2 RS701 RS702 RD07 FW703 RD06 1 6 SW705 DISC1 RD05 7 6 5 4 3 2 SW704 TIMER/SLEEP 1 D703 8 LED722 FL701 22 21 20 19 18 17 16 15 14 13 12 11 10 9 RD03 SW703 CLOCK RX701 RD02 C715 80 1 RD04 85 75 70 R798 1 FW703 R710 R711 R712 R713 R714 R730 R702 R703 R717 6 RD01 R735 R705 R720 R736 R740 R739 R737 31 R741 30 40 R715 25 35 R701 50 R731 45 20 R726 51 55 1 C714 R709 60 15 R732 IC701 3 2 R727 65 R738 R742 R719 R750 SW701 POWER R748 R747 R752 R753 R745 SW711 REC/ PAUSE R754 R780 R734 LED718 RD13 RD15 RD14 LED720 SW712 MEMORY/ SET SW716 TAPE LED719 LED716 RD12 R733 R751 RD11 SW713 STOP RD16 SW717 CD RD10 R756 SW710 REW R755 SW714 TUNER(BAND) COLOR TABLE CNS701 1 7 9 11 13 15 17 19 21 23 5 3 2 4 R783 6 LED721 8 10 12 14 16 18 20 22 24 BR BROWN R D ( R) RED OR ORANGE YL YELLOW GR GREEN C673 FFC701 24 R782 R784 SW715 VIDEO/ AUX R785 57 R743 44 CNP701 JK671 HEADPHONES P28 6 - A TO MAIN PWB 7 8 9 10 Figure 31 WIRING SIDE OF P.W.BOARD (4/8) – 31 – 11 BL BLUE VL VIOLET GY GRAY WH ( W) WHITE BK BLACK PK PINK 12 CD-C662 A F801 5A/125V AC POWER SUPPLY CORD (249) AC120V, 60Hz B C801 D801 C T.F RL801 D T802 POWER TRANSFORMER R803 C820 B C E E T801 POWER TRANSFORMER ZD802 C802 Q802 D804 D802 D803 D805 F804 5A/125V F805 5A/125V R804 C818 C819 ZD801 R802 C810 CNS704 L802 1 2 3 4 5 6 R805 C804 D808 TO DISPLAY PWB F806 2A/250V C812 D806 R801 P30 1 - H Q803 D807 F C817 1 2 3 Q801 B C E C803 C805 C809 C816 D809 D810 D817 CNP704 D816 CNP802 CNP801 P29 12 - F D811 3 2 1 CNS801 TO MAIN PWB C813 D813 C814 D812 C815 C811 G D815 D814 H 1 2 3 4 5 6 7 8 POWER SUPPLY PWB-B1 1 2 3 4 Figure 32 WIRING SIDE OF P.W.BOARD (5/8) – 32 – 5 6 CD-C662 6ohms R-CH R959 R960 R934 1 2 3 RL901 D911 E C B Q903 R930 R928 D907 D908 R926 3 2 1 Q911 Q910 3 2 1 C930 R929 C929 R932 R916 R915 D903 L902 ZD901 D905 B C E Q904 R923 R931 R925 R927 L901 D906 R942 D909 ZD902 C922 E C B Q901 Q902 E C B R920 IC901 C924 R941 C957 Q905 C925 D904 1 2 3 4 5 6 C923 R922 R918 R919 R921 R917 C919 C920 R912 R904 R902 C912 R962 R961 C914 R901 R903 R906 P28 6 - H CNS901 TO MAIN PWB C913 C916 R908 C918 R910 C911 R913 CNP901 1 2 3 4 5 6 7 8 9 10111213 R911 20 21 22 SO901 SPEAKER TERMINAL R933 D910 C956 C921 7 8 9 10 11 12 13 14 15 16 17 18 19 L-CH R958 C952 R953 D913 R954 R905 M901 FAN MOTOR C917 R909 C915 C951 ZD951 E C B R907 Q908 B C E Q909 C955 R956 BR R955 R957 RD R943 CNS903 2 1 COLOR TABLE C901 C903 CNS802 1 2 3 4 5 6 7 8 RD RD WH GY GY WH GY GY R935 R936 RED OR ORANGE YL YELLOW GR GREEN R938 R939 C904 C902 1 2 1 C943 BI802 CNP903 8 BL BLUE VL VIOLET B C E GY GRAY Q907 WH(W) WHITE BK BLACK PK PINK D902 C945 POWER AMP. PWB-B2 7 8 9 10 Figure 33 WIRING SIDE OF P.W.BOARD (6/8) – 33 – BROWN R937 D912 D901 BR RD(R) 11 12 CD-C662 SWM3 F. P. (260-9) 2 1 A FWM2 FWM1 PHM1 4 3 SWM4 F. A. S (260-10) WH BK CNPM2 BK WH SOLM1 SOLENOID (260-8) + TAPE MECHANISM PWB-F - 1 2 P30 5 - H CNSM1 TO DISPLAY PWB R 12 11 10 9 8 7 6 5 4 3 2 1 CNPM1 1 2 MM1 TAPE MOTOR(260-7) SWM5 CAM(260-11) TAPE MECHANISM ASSEMBLY B TAPE 1 PLAYBACK HEAD(260-6) TAPE 2 RECORD/PLAYBACK HEAD(260-6) ERASE HEAD(260-5) PICKUP UNIT(306) WH WH BK YL BK GY RD WH GY WH GY WH GY WH 1 2 3 4 5 6 7 8 D BK WH PK YL BL 1 2 3 4 5 CNS2B BK 1234567 CNP102 CNP101 TO MAIN PWB P29 12 - D 1 2 3 4 5 6 7 8 GY WH PK BK WH YL BL CNS102 BL PK WH YL BK CNS101 PK 1 2 3 4 5 321 CNS1A CNS1B GY BK WH GY C PK WH BL PK TO MAIN PWB P29 12 - C CNS2A COLOR TABLE CD MOTOR PWB-D E RD WH GY WH GY WH 1 2 3 4 5 6 + CNP3A 1 2 3 4 5 6 1 2 3 4 5 6 CNS3A M2 SLED MOTOR BR SW4 PICK UP IN CNS3B + - M1 SPINDLE MOTOR F CNS5 SW2 MECHA UP 2 1 ORANGE YL YELLOW GR GREEN BL BLUE VL VIOLET GY GRAY WH(W) WHITE BK BLACK PK PINK SENSOR PWB-E M3 T/T UP/DOWN LOADING OR BR WH GY WH GY WH GY WH RD 1 - SOLENOID SOLM2 BIM5 CNS10 10 9 8 7 6 5 4 3 2 1 RED OR SW3 DISC NUMBER 2 1 SW1 OPEN/CLOSE G BROWN RD(R) + 6 H 1 2 3 4 Figure 34 WIRING SIDE OF P.W.BOARD (7/8) – 34 – 5 6 CD-C662 11 CNP2 CNP99 C18 1 2 3 6 Q51 R81 R80 R83 1 2 3 4 5 6 D92 C55 R84 21 1 20 C77 5 15 10 IC3 8 7 6 5 4 3 2 1 25 30 35 CNP3 CNP10 40 1 2 3 4 5 6 7 8 9 10 42 22 C36 1 C82 10 D91 7 C98 IC99 1 2 3 1 3 L99 CNS99 1 2 3 DIGITAL OUTPUT PWB-A4 • The numbers 1 to 12 are waveform numbers shown in page 14. 8 CNS12 BI1A Q52 R32 R66 R64 C75 C52 D93 R37 7 P30 3 - H TO DISPLAY PWB R17 R18 R23 R24 R29 R56 8 ZD61 2 1 R82 R13 1 2 3 4 5 6 B 3 1 2 CNP11 R14 C9 R16 R25 C14 R20 C11 R21 C76 C35 R26 R22 C6 R10 C10 R15 C8 C54 C4 R12 C7 R8 R9 R11 C5 C19 17 16 1 2 3 4 5 C13 C51 BI99 C15 R2 C2 15 E C R31 10 32 25 20 R33 IC1 C20 5 33 35 30 C17 R30 1 40 C16 R27 R28 C1 60 R34 45 R19 E C83 D81 C71 48 55 64 C3 Q1 C C12 2 CNP1 R36 R35 C33 C32 C34 C31 49 CNS11 R89 C29 P29 8 - B TO MAIN PWB 17 R71 16 C22 C28 R46 R1 C74 R74 C73 R73 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 R91 L61 C24 C21 B R65 R44 50 9 1 2 C72 C99 R43 32 C50 C56 R72 R54 R55 1 33 BI1B 64 CNP12 40 60 IC2 35 30 5 25 10 20 15 R90 R88 R53 R93 45 R45 4 C43 48 55 R50 C57 C23 R39 C30 D1 5 3 R38 C25 R40 D82 49 R52 C26 R42 R41 C27 C41 C44 XL1 50 C39 R51 C40 C42 R61 C49 R57 R62 R63 R58 C45 R59 C47 C38 C46 R60 C37 R47 C48 CD SERVO PWB-C 9 10 Figure 35 WIRING SIDE OF P.W.BOARD (8/8) – 35 – 11 12 CD-C662 TROUBLESHOOTING (CD SECTION) When the CD does not function When the CD section does not operate when the objective lens of the optical pickup is dirty, this section may not operate. Clean the objective lens, and check the playback operation. When this section does not operate even after the above step is taken, check the following items. Remove the cabinet and follow the troubleshooting instructions. "Track skipping and/or no TOC (Table Of Contents) may be caused by build up of dust other foreign matter on the laser pickup lens. Before attempting any adjustment make certain that the lens is clean. If not, clean it as mentioned below." Turn the power off. Gently clean the lens with a lens cleaning tissue and a small amount of isopropyl alcohol. Do not touch the lens with the bare hand. Dust gradually accumulates on the objective lens during use, and it may degrade performance. To avoid this problem, use a cleaning disc designed for CD optical pickup lenses. HOW TO USE 1. Using the brush in the cleaner cap, apply 1 or 2 drops of the cleaning fluid to the brush on the CD cleaner disc which has the mark next to it. 2. Place the CD cleaner disc onto the CD disc tray with the brush side down, then press the play button. 3. You will hear music for about 20 seconds and the CD player will automatically stop. If it continues to turn, press the stop button. CAUTION The CD lens cleaner should be effective for 30 - 50 operations, however if the brushes become worn out earlier then please replace the cleaner disc. If the CD cleaner brushes become very wet then wipe off any excess fluid with a soft cloth. Do not drink the cleaner fluid or allow it to come in contact with the eyes. In the event of this happening then drink and / or rinse with clean water and seek medical advice. The CD cleaner disc must not be used on car CD player or on computer CD ROM drives. All rights reserved. Unauthorized duplicating, broadcasting and renting product is prohibited by law. Cleaning Disc PARTS CODE: UDSKA0004AFZZ Cleaner Liquid Figure 36 – 36 – CD-C662 • When the turntable fails to stop. 5V Is from 2.5V 5 V till 2.5V down pulse (approx. 300 ms) 0V No input into the IC701 pin 21 when the turntable is rotating? Check the SWM3 and the wiring from the IC701 pin 21 to the SWM3. Yes Is there following voltage input on the IC701 pin 21 in the specific state? When the CD mechanism is moved up: 0V In other states: 4.3V No Check the MECHA UP SW and the wiring from the IC701 pin 21 to the MECHA UP SW. Yes Check IC2 pin26 the periphery. Yes IC701 defective. • When turntable fails to move. Is there following voltage input on the IC701 pin 21 in the specific state? When the CD mechanism is moved up: 0V In other states: 4.3V No Check the MECHA UP SW and the wiring from the IC701 pin 21 to the MECHA UP SW. Yes Is L output from the IC2 pin 26 during SEC when the disc skip switch is pressed? Check the wiring of IC2 pin 26. No OK Yes IC2 defective. Check turntable motor and turntable mechanism. – 37 – CD-C662 • When the CD tray fails to open or close. Is there following voltage input in specific state of IC701 pin 19? Open state: 0V Close state: 0V Intermediate state between open state and close state: 4.3V Check the OPEN CLOSE SW and the wiring from the IC701 pin 19 to the OPEN CLOSE SW. No Yes Is H output to IC2 pin 24 or 25 for 7 seconds when the OPEN/ CLOSE key is pressed?IC91 is defective. Replace it. Check the wiring of the IC2 pins 24 and 25, IC91 pins 1 and 3. No OK IC2 defective. Yes Is 4V output between IC91 pins 3 and 7 during operation stated above? Check the periphery of IC91. No OK Yes IC91 defective. Check the loading motor (M1) and the loading mechanism. • The CD function will not work. The CD operating keys don't work. Yes Check the CD, DSP, power supply, and 16.93 MHz clock, and reset terminal. Yes Check the waveform of SCK, SO (DATA) and SI (COMM). Yes See if the pick-up is in the PICKUP IN SW position. Yes Focus search is performed two times when play operation is done without disc. 0.5s 0.50 V IC1 16 FD If the items mentioned above are OK, check the main microcomputer IC701. • The CD operating keys work. 0.5s 0.50 V IC1 7 TE Check the Focus - HF system. 1 Playback can be performed without a disc. 2 Figure 38 Yes Does the pick-up move up and down twice? Yes Focus search OK No Does the output waveform of IC1(16)(FD) match that shown in Fig. 38? Check the area around IC5-CNP2. Yes No Check the IC1(50)(CLK) line, 4MHz. Check the microcomputer data on pins (51)(CL), (52)(DAT) and (53)CE. – 38 – CD-C662 • Playback can only be performed when a disc is loaded. Is the Focus servo active? (Can you hear it working?) No Check the laser diode driver. Check the area around IC1(16) - (21) (focus servo circuit). No If the disc is not turning, the DRF should not change to "H". Yes Yes Does the DRF signal change from "L" to "H"? Check the spin system. Yes Yes No Is HF waveform normal (see the Fig. 39-1, 2)? Check the periphery of IC1 pins 41 and 42. Level is abnormal. Yes Yes Check the spin system. Waveform is unstable. Check the tracking system. HF 1.0V/DIV 0.5µsec/DIV(DC) (When playing back the disc) Waveform in case of normal play-back 0.5s 1.00 V IC1 16 FD 0.5s 10.0 V IC2 13 CLV+ 2 1 3 0.5s 10.0 V IC1 54 DRF 4 0.5s 2.00 V IC1 7 TE Figure 39-1 Figure 39-2 • Check the tracking system. Check waveform of IC1 pin 7 (TE). The waveform shown in Fig. 39-3 appears, and no-disc state appears soon. Play is possible in TEST mode. Yes Yes Data cannot be read. Tracking servo is inoperative. Yes Although IL is possible, play is impossible. Yes Yes Check the periphery of IC 1 pin 8 to pin 15, and IC 5 to CNP2. Normal jump is impeded, and the program top cannot be reached. Check the VCO-PLL system. 5ms 1.00 V IC1 7 TE 4 5 ms 5.0 V IC1 54 DRF 3 Figure 39-3 – 39 – Yes Check the periphery of IC 1 pin 14. CD-C662 • Checking the spin system. Play operation is performed without disc. Yes Yes The turntable rotates a little. The spin driver circuit is normal. No Yes The turntable fails to rotate or rotates at high speed. Check the periphery of IC1 pins 23 to 27, pin 39, and pin 40, IC2 pin 12 and pin 13, IC5 to CNP3. • Checking the VCO-PLL system Play operation is performed when disc exits. Yes Although HF waveform is normal, TOC data cannot be read. Yes Check PDO waveform (Fig. 40). Abnormal Check the IC1 pins 43 and 44, IC2 pins 3, 5, 7, 10, and 11. Stop --> Play As VCO frequency is locked at 4.32 M Hz, voltage of PDO rises and stabilizes. 0.5s 1.00 V IC2 3 PDO 2 0.5s 1.00 V IC2 16 FD 3 Figure 40 • Although HF waveform is normal and the time indication is normal, no sound is emitted. No Check IC 2 pin 48 (EFLG). Yes Check IC2 pins 37, 40. Abnomal Check IC 401 and POWER AMP IC 801. – 40 – Usually, the number of pulses of flawless disc is 100 pulses/sec or less. CD-C662 FUNCTION TABLE OF IC IC1 VHiLA9241M/-1: Servo Amp. (LA9241M) (1/2) Pin No. Function Port Name 1 FIN2 Connection pin for photodiode of pickup. RF signal is generated through addition with FIN pin, and FE signal is generated through subtraction. 2 FIN1 Connection pin for photodiode of pickup. 3 E Connection pin for photodiode of pickup. TE signal is generated through subtraction with F pin. 4 F Connection pin for photodiode of pickup. 5 TB Pin for input of DC component of TE signal. 6 TE- Pin to connect gain setting resistor of TE signal to TE signal. 7 TE TE signal output pin. 8 TESI TES (Track error sense) comparator input pin. TE signal is band-passed and input. 9 SCI Input pin for shock detection. 10 TH Pin to set time constant of tracking gain. 11* TA TA amplifier output pin. 12 TD- Pin to compose tracking phase compensation constant between TD and VR pins. 13 TD Pin to set tracking phase compensation. 14 JP Pin to set amplitude of tracking jump signal (kick pulse). 15 TO Tracking control signal output pin. 16 FD Focusing control signal output pin. 17 FD- Pin to compose focusing phase compensation constant between FD and FA pins. 18 FA Pin to compose focusing phase compensation constant between FD-/FA-pins. 19 FA- Pin to compose focusing phase compensation constant between FA and FE pins. 20 FE Output pin of FE signal. 21 FE- Pin to connect gain setting resistor of FE signal across TE pin. 22 AGND GND for analog signal. 23 NC No connect. 24 SPI Spindle amplifier input. 25 SPG Pin to connect gain setting resistor in the 12cm mode of spindle. 26 SP- Pin to connect spindle phase compensation constant together with SPD pin. 27 SPD Spindle control signal output pin. 28 SLEQ Pin to connect thread phase compensation constant. 29 SLD Thread control signal output pin. 30 SL- Input pin of thread feed signal from micro computer. 31 SL+ Input pin of thread feed signal from micro computer. 32 JP- Input pin of tracking jump signal from DSP. 33 JP+ Input pin of tracking jump signal from DSP. 34 TGL Input pin of tracking gain control signal from DSP. TGL = Gain low at "H" 35 TOFF Input pin of tracking off control signal from DSP. TOFF = Off at "H" 36 TES Output pin of TES signal to DSP. 37 HFL (HIGH FREQUENCY LEVEL) is used to judge whether main beam is positioned on the bit or on the mirror. 38 SLOF Thread servo off control input pin. 39 CV- Pin to input CLV error signal from DSP. 40 CV+ Pin to input CLV error signal from DSP. 41 RFSM RF output pin. 42 RFS- Pin to set gain of RF and set 3T compensation constant together with RFSM pin. 43 SLC (SLICE LEVEL CONTROL) is the output pin to control of the level of the data slice with RF waveform DSP. 44 SLI Input pin to control the level of data slice with DSP. 45 DGND GND pin in the digital system. 46 FSC Output pin for focus search smoothening capacitor. 47 TBC (Tracking Balance Control) Pin to set EF balance variable range. 48* NC No connect. 49 DEF Defect detection output pin of disk. 50 CLK Reference clock input pin. 4.23MHz of DSP is input. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. – 41 – CD-C662 IC1 VHiLA9241M/-1:Servo Amp. (LA9241M) (2/2) Pin No. Function Port Name 51 CL Micro computer command clock input pin. 52 DAT Micro computer command data input pin. 53 CE Micro computer command chip enable input pin. 54 DRF (DETECT RF) RF level detection output. 55 FSS (Focus Serch Select) Pin to switch focus search mode. (± search/+ search for reference voltage) 56 VCC2 VCC pin for servo system and digital system. 57 REFI Pin to connect pass control for reference voltage. 58 VR Reference voltage output pin. 59 LF2 Pin to set defect detection time constant of disk. 60 PH1 Pin to connect capacitor for peak hold of RF signal. 61 BH1 Pin to connect capacitor for bottom hold of RF signal. 62 LDD APC circuit output pin. 63 LDS APC circuit output pin. 64 VCC1 RF system VCC pin. LDS 63 VCC1 64 LDD 62 BH1 61 PH1 60 APC FIN2 1 FIN1 2 3 F 4 TB 5 TE- 6 TE 7 TESI 8 SCI 9 VR 58 REFI 57 VCC2 56 FSS DRF CE DAT CL CLK 55 54 53 52 51 50 DEF 49 REF RF DET 48 NC 47 TBC VCA I/V E LP2 59 46 FSC BAL µ-COM VCA 45 DGND SLC INTER FACE 44 SLI 43 SLC 42 RFS- TE 41 RFSM RF AMP 40 CV+ 39 CV- T.SERVO & T.LOGIC 38 SLOF TH 10 37 HFL 36 TES TA 11 35 TOFF 34 TGL TD- 12 F.SERVO & F.LOGIC SPINDLE SERVO 33 JP+ SLED SERVO TD 13 JP 14 TO 15 FD 16 17 FD- 18 FA 19 FA- 20 FE 21 22 23 NC FE- AGND SP 24 SPI Figure 42 BLOCK DIAGRAM OF IC – 42 – 25 SPG 26 SP- 27 SPD 28 SLEQ 29 SLD 30 31 SL- SL+ 32 JP- CD-C662 IC2 VHiLC78622N-1: Servo/Signal Control (LC78622N) (1/2) Pin No. Terminal Name Input/Output Function 1 DEFI Input Defect detection signal (DFF) input terminal. (When this terminal is not used, connect it to 0V.) 2 TAI Input For PLL Input terminal for test. Pull-down resistor built in. Be sure to connect this terminal to 0V. 3 PDO 4 VVSS — 5 ISET Input 6 VVDD — 7 FR 8 VSS 9 EFMO Output 10 EFMIN Input 11 TEST2 Input 12 CLV+ Outout 13 CLV- Output Output for disc motor control. 3-value output is enabled according to command. 14 V/P Output Rough servo/phase control automatic selection monitor output terminal. "H": Rough servo, "L": Phase servo 15 HLF Intput Track detection signal input terminal. Schmidt input. 16 TES Input Tracking error signal input terminal. Schmidt input. 17 TOFF 18 19 Output Input — Phase comparison output terminal for external VCO control. Grounding terminal for built-in VCO. Be sure to connect this terminal to 0V. Resistor connection terminal for adjustment of PDO output current. Power terminal for built-in VCO. For VCO frequency range adjustment. Digital system grounding terminal. Be sure to connect this terminal to 0V. For slice level control EFM signal output terminal. EFM signal input terminal. Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V. Output for disc motor control. 3-value output is enabled according to command. Output Tracking OFF output terminal. TGL Output Output terminal for tracking gain selection. "L": Gain raising. JP+ Output Output for track jump control. 3-value output is enabled according to command. 20 JP- Output Output for track jump control. 3-value output is enabled according to command. 21* PCK Output Clock monitor terminal for EFM data play-back. Phase lock: 4.3218 MHz. 22* FSEQ Output Sync signal detection output terminal. When the sync signal detected from the EFM signal coincides with the internally generated sync signal: "H" 23 VDD 24 CONT1 Input/Output General-use input/output terminal 1. 25 CONT2 Input/Output General-use input/output terminal 2. 26 CONT3 Input/Output General-use input/output terminal 3. 27 CONT4 Input/Output General-use input/output terminal 4. 28* CONT5 Input/Output General-use input/output terminal 5. 29* EMPH/CONT6 Output Deemphasis monitor terminal. "H": Deemphasis disc play-back. General-use output terminal 6. 30* C2F Output C2 flag output terminal. 31 DOUT Output Digital OUT output terminal. (EIAJ format) 32* TEST3 Input Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V. 33 TEST4 Input Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V. 34 PCCL Input General-use input/output command recognition terminal. Pull-down resistor built in. When this terminal is used for the same function as that of LC78622E, open or connect this terminal to 0V. H: Only the general-use input/output port command is controllable. L: All command controls are enabled. 35* MUTEL/CONT7 36 LVDD — 37 LCHO Output 38 LVSS — 39 RVSS — 40 RCHO Output 41 RVDD — 42* MUTER/CONT8 43 XVDD — 44 XOUT Output 16.9344 MHz crystal oscillator connection terminal. 45 XIN Input 16.9344 MHz crystal oscillator connection terminal. 46 XVSS — Output Output — Digital system power terminal. L channel 1-bit DAC Control with serial data command from microcomputer. When this terminal is not used, set it as an input terminal and connect to 0V or set it as an output terminal and open. Mute output terminal for L channel. General-use output terminal 7. Power terminal for L channel. L channel output terminal. Grounding terminal for L channel. Be sure to connect this terminal to 0V. R channel 1-bit DAC Grounding terminal for R channel. Be sure to connect this terminal to 0V. R channel output terminal. Power terminal for R channel. Mute output terminal for R channel. General-use output terminal 8. Power terminal for crystal oscillation. Grounding terminal for crystal oscillation. Be sure to connect this terminal to 0V. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. – 43 – CD-C662 IC2 VHiLC78622N-1: Servo/Signal Control (LC78622N) (2/2) Pin No. Terminal Name Input/Output Function 47* SBSY Output Sub-code clock sync signal output terminal. 48* EFLG Output C1, C2, single, double correction monitor terminal. 49* PW Output Sub-code P, Q, R, S, T, U, and W output terminal. 50* SFSY Output Sub-code frame sync signal output terminal. Falling occurs when the sub-code is in standby state. Input Sub-code read clock input terminal. Schmidt input (When this terminal is not used, connect it to 0V.) 51 SBCK 52* FSX Output 7.35 kHz sync signal (frequency-divided from crystal oscillation) output terminal. 53 WRQ Output Sub-code Q output standby output terminal. 54 RWC 55 SQOUT 56 COIN Input Command input terminal from microcomputer. 57 CQCK Input Command input taking-in clock or sub-code taking-out (from SQOUT) clock input terminal. Schmidt input 58 RES Input LSI resetting input terminal. When power is turned on, once "L" is set. 59* TEST11 Output Output terminal for test. Use this terminal in open state (usually "L" output). 60* 16M Output 16.9344 MHz output terminal. 61 4.2M Output 4.2336 MHz output terminal. 62 TEST5 Input Input terminal for test. Pull-down resistor built-in. Be sure to connect this terminal to 0V. 63 CS Input Chip selection input terminal. Pull-down resistor built-in. In noncontrol state connect this terminal to 0V. 64 TEST1 Input Input terminal for test. Pull-down resistor is not provided. Be sure to connect this terminal to 0V. Input Read/Write control input terminal. Schmidt input. Output Sub-code Q output terminal. Note: The same potential must be supplied to the power terminals (VDD, VVDD, LVDD, RVDD, XVDD). DEFI EFMIN FSEQ Slice level control Vss VDD TAI TST11 TEST1 TEST2 TEST3 TEST4 TEST5 PCK FR I SET PDO VVDD VVss EFMO In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. RAM address generator 2K x 8bit RAM VCO colck oscillation clock control Sync detection EFM demodulation Interpolation mute C2F Bilingual Digital OUT CLV+ CLV- CLV Digital servo Flag processing of C1/C2 error detection and correction Digital attenuator V/P PW SBCK SBSY SFSY CS WRQ SQOUT Subcode division QCRC X4 oversampling digital filter µCOM Interface 1bitDAC CQCK Figure 44 BLOCK DIAGRAM OF IC – 44 – MUTEL/CONT8 LVss LVDD LCHO RCHO EFLG EMPH/CONT6 TGL PCCL CONT1 CONT2 CONT3 CONT4 CONT5 JPJP+ RES RWC HFL TES TOFF L.P.F XTAL system timing generator General-use port RVss RVDD MUTER/CONT7 Servo commander 16M 4.2M XVss FSX XIN XOUT XVDD COIN DOUT CD-C662 IC3 VHiM63001FP-1: Focus/Tracking/Spin/Slide Driver (M63001FP) 1 2 3 4 5 6 7 8-14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29-35 36 37 38 39 40 41 42 Terminal Name Function IN2IN1AIN1BOUT1OUT1+ OUT2OUT2+ GND OUT3+ OUT3IN3VCC1 STANDBY VRFE MUTE IN5IN5+ VCC2 IN4OUT4OUT4+ VCC3 GND OUT5+ OUT5OUT6+ OUT6VCC4 IN6IN6+ CH2 inverted input. CH1 inverted input. CH1 output offset control. CH1 inverted output. CH1 non-inverted output. CH2 inverted output. CH2 non-inverted output. GND CH3 non-inverted output. CH3 inverted output. CH3 inverted input. Power supply 1 (CH1, CH2, CH3) STANDBY signal input. CH1-CH4 Reference voltage input. Mute signal input (CH6). CH5 inverted input. CH5 non-inverted input. Power supply 2 (CH4). CH4 inverted input. CH4 inverted output. CH4 non-inverted output. Power supply 3 (CH5). GND CH5 non-inverted output. CH5 inverted output. CH6 non-inverted output. CH6 inverted output. Power supply 4 (CH6). CH6 inverted input. CH6 non-inverted input. IN2– 1 42 IN6+ IN1A– 2 41 IN6– IN1B– 3 40 VCC4 OUT1– 4 39 OUT6– OUT1+ 5 38 OUT6+ OUT2– 6 37 OUT5– OUT2+ 7 36 OUT5+ 1 –IN A 2 +IN A 3 VEE 4 A – + + B – 8 VCC 7 OUT E 6 –IN B 5 +IN B GND INB1 3 18 INB2 INC1 4 17 INC2 IND1 5 TONE1 6 TONEL1 7 OUT1 8 GND 9 Vcc 10 M62439FP 19 INA2 34 11 32 GND 31 13 30 14 29 15 28 VCC3 OUT3– 16 27 OUT4+ IN3– 17 26 OUT4– VCC1 18 25 IN4– STANDBY 19 24 VCC2 VTEF 20 23 IN5+ 21 22 IN5– MUTE 16 IND2 15 TONE2 14 TONEL2 13 OUT2 12 Vss 11 CONT Figure 45 BLOCK DIAGRAM OF IC – 45 – 33 OUT3+ 20 REC OUT2 INA1 2 9 12 IC601 VHiM62439SP-1: Audio Processor (M62439SP) REC OUT1 1 35 10 IC562,563 VHiKiA4558P-1: Ope Amp. (KIA4558P) OUT A 8 M63001FP Pin No. CD-C662 IC701 RH-iX0301AWZZ:System Microcomputer (IX0301AW) (1/2) Pin No. Port Name Terminal Name Input/Output 1 VDD VDD — 2* P37 ENA Output 3 P36 DO Input 4 P35 DI Output DATA OUTPUT 5 P34 CE Output CE OUTPUT 6 P33 CLK Output CLOCK OUTPUT 7,8 P32, P31 LCK1, LCK2 Output 9 P30 RWC Output 10 RESET RESET 11 X2 X2 Output MAIN CLOCK 12 X1 X1 Input MAIN CLOCK 13 Vpp VPP — POWER SUPPLY TERMINAL 14* XT2 XT2 — OPEN 15 P04 WRQ Input 16 VDD VDD — 17 P27 PCCL Output CD DSP PCCL 18 P26 COIN Outout CD DSP COMAND 19 P25 SQOUT Input 20 P24 CQCK Output 21 P23 DSP RES Output 22 P22 FRF (DRF) Input 23 P21 SLD+ Output CD SLIDE MOTOR + 24 P20 SLD- Output CD SLIDE MOTOR - 25 AVss AVSS — ANALOG GROUND 26 ANI7 SPEANA3 Input 27 ANI6 SPEANA2 Input SPEANA DATA INPUT 1 KHz 28 ANI5 SPEANA1 Input SPEANA DATA INPUT 63 Hz 29* ANI4 TUN SM Input TUNER SIGNAL METER INPUT 30 ANI3 T2 RUN Input TAPE2 RUN PULSE INPUT 31-33 ANI2-ANI0 KEYIN3-KEYIN1 Input 34 AVDD AVDD 35 AVREF AVREF 36 P03 PUIN SW Input CD PUIN SWITCH 37 P02 O/C SW Input CD OPEN/CLOSE SWITCH 38 INTP1 SYS STOP Input SYSTEM STOP INPUT 39 INTP0 REMOCON Input REMOCON INPUT 40 Vss VSS 41 P74 DNO SW Input CD DISC NO. SWITCH 42 P73 U/D SW Input CD UP/DOWN SWITCH 43 P72 TIMER LED Output TIMER LED CONTROL 44 P71 T_SOL Output TAPE SOLENOID CONTROL 45 P70 T_MOT Output TAPE MOTOR CONTROL 46 VDD VDD 47 P127 48 P126 49 Input Function (+) POWER SUPPLY DOLBY PROLOGIC ENABLE TERMINAL DATA INPUT CD DSP READ WRITE CONTROL RESET CD DSP WRITE REQUEST (+) POWER SUPPLY CD DSP CODE Q OUT CD DSP CLOCK CD DSP RESET CD RF LEVEL DETECTION SPEANA DATA INPUT 16 KHz KEY INPUT — ANALOG VDD — ANALOG REF VOLTAGE — GROUND VOLTAGE — (+) POWER SUPPLY CAM SW Input TAPE CAM SWITCH TIFAS Input TAPE1 FULL AUTOSTOP PULSE INPUT P125 FPA Input TAPE2 A-SIDE FULL PROOF 50 P124 H/P 51 P123 AC RLY_CONT 52 P122 REC/PLAY Output TAPE REC/PLAY CHANGE 53 P121 T_BIAS Output TAPE Record bias control 54 P120 T_T1T2 Output TAPE T1/T2 CHANGE 55 P117 DISTO Input DISTINATION INPUT Input HEADPHONE INPUT Output AC RELAY CONTROL In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. – 46 – CD-C662 IC701 RH-iX0301AWZZ:System Microcomputer (IX0301AW) (2/2) Pin No. Port Name Terminal Name Input/Output 56 P116 KEY JOG A Input KEY JOG INPUT A 57 P115 KEY JOG B Input KEY JOG INPUT B 58 P114 S MUTE Output 59* P113 C MUTE Output CENTER MUTE 60* P112 SR MUTE Output SURROUND MUTE 61 P111 HI-CUT Output HI-CUT OUTPUT 62* P110 POWER Output POWER OUTPUT 63 P107 SP_RLY Output SPEAKER OUTPUT RELAY CONTROL Function SYSTEM MUTE 64 P106 SP_DET Input SPEAKER OUTPUT DETECTION 65 P105 SPN_P Input TUNER SPAN CHANGE 66 P104 DISTOUT Output DISTINATION OUTPUT 67 P103/FIP32 DIAT4/P22 Input/Output FL DISPLAY SEGMENT DRIVER DISTINATION INPUT 68 P102/FIP31 DIAT3/P21 Input/Output FL DISPLAY SEGMENT DRIVER DISTINATION INPUT 69 P101/FIP30 DIAT2/P20/P15 Input/Output FL DISPLAY SEGMENT DRIVER DISTINATION INPUT 70 P100/FIP29 DIAT1/P19/P16 Input/Output FL DISPLAY SEGMENT DRIVER DISTINATION INPUT 71-78 FIP28-FIP21 P18/P13-P11/P7 79 VLOAD VLOAD 80-100 FIP20-FIP0 P10/P6-G1/9G Output — Output FL DISPLAY SEGMENT DRIVER FL DRIVER (–) POWER SUPP, –30V FL DISPLAY SEGMENT DRIVER In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. – 47 – CD-C662 FL701 VVKBJ685GNK-1: FL Display 11G 9G 10G SI S1 S5 S4 S3 S2 CO Dp B7 B6 B5 B4 B3 B1 B1 B2 1G 2G 3G 4G 5G 6G 7G 8G a h B7 B8 B9 B10 B11 B12 B13 B14 B21 B20 B19 B18 B17 B16 B15 j f B6 B5 b k g m n r B4 B3 B2 e p c d B1 [ 1G~8G ] [ 10G ] ANODE CONNECTION 1G 2G~6G 7G 8G 9G 10G 11G P1 Dp Dp Dp Dp S1 S1 S1 P2 d d d d B1 B1 B1 P3 c c c c B2 B2 B2 P4 n n n n B3 B3 B3 P5 p p p p B4 B4 B4 P6 r r r r B5 B5 B5 P7 e e e e B6 B6 B6 P8 m m m m B7 B7 B7 P9 g g g g B8 co P10 B9 P11 b b b b B10 P12 k k k k B11 P13 j j j j B12 P14 h h h h B13 P15 f f f f P16 a a a a B15 P17 S2 S2 S2 S2 B16 P18 S3 S3 S3 S3 B17 P19 S4 S4 S4 S4 B18 P20 S5 S5 S5 S5 B19 (LOWER) B14 P21 B20 P22 B21 Figure 48 FL DISPLAY – 48 – B2 B3 B4 B5 B6 B7 CD-C662 PARTS GUIDE CD-C662 MODEL CD-C662 mini component system consisting of CD-C662 (Main unit) and CP-C662 and (Speaker system). “HOW TO ORDER REPLACEMENT PARTS” To have your order filled promptly and correctly, please furnish the following information. 1. MODEL NUMBER 2. REF. No. 3. PART NO. 4. DESCRIPTION For U.S.A. only Contact your nearest SHARP Parts Distributor to order. For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP MARK: SPARE PARTS-DELIVERY SECTION Explanation of capacitors/resistors parts codes Capacitors Resistors VCC ....................... Ceramic type VCK ........................ Ceramic type VCT ........................ Semiconductor type VC • • MF ............... Cylindrical type (without lead wire) VC • • MN ............... Cylindrical type (without lead wire) VC • • TV ................ Square type (without lead wire) VC • • TQ ............... Square type (without lead wire) VC • • CY ............... Square type (without lead wire) VC • • CZ ............... Square type (without lead wire) VC • • • • • • • • • J .. The 13th character represents capacity difference. ("J" ±5%, "K" ±10%, "M" ±20%, "N" ±30%, "C" ±0.25 pF, "D" ±0.5 pF, "Z" +80-20%.) VRD ....................... Carbon-film type VRS ........................ Carbon-film type VRN ....................... Metal-film type VR • • MF ............... Cylindrical type (without lead wire) VR • • MN ............... Cylindrical type (without lead wire) VR • • TV ................ Square type (without lead wire) VR • • TQ ............... Square type (without lead wire) VR • • CY ............... Square type (without lead wire) VR • • CZ ............... Square type (without lead wire) VR • • • • • • • • • J .. The 13th character represents error. ("J" ±5%, "F" ±1%, "D" ±0.5%.) If there are no indications for the electrolytic capacitors, error is ±20%. If there are no indications for other parts, the resistors are ±5% carbon-film type. NOTE: Parts marked with “ ” are important for maintaining the safety of the set. Be sure to replace parts with specified ones for maintaining the safety and performance of the set. – 49 – CD-C662 NO. PRICE RANK PARTS CODE DESCRIPTION CD-C662 INTEGRATED CIRCUITS IC1 IC2 IC3 VHILA9241M/-1 VHILC78622N-1 VHIM63001FP-1 J J J IC101 VHIAN7345K/-1 J IC301 IC302 IC303 IC562,563 IC601 IC701 VHITA7358AP-1 VHILC72131/-1 VHILA1805//-1 VHIKIA4558P-1 VHIM62439SP-1 RH-IX0301AWZZ J J J J J J IC702,703 IC704 IC901 VHIBU2092F/-1 VHIKIA7042AP1 VHISTK4113E-1 J J J AS Servo Amp.,LA9241M AY Servo/Signal Control,LC78622N AX Focus/Trackig/Spin/Slide Driver, M63001FP AM Playback and Record/Playback Amp.,AN7345K AG FM Front End,TA7358AP AP PLL (Tuner),LC72131 AM FM/AM IF MPX.,LA1805 AC Ope Amp.,KIA4558P AG Audio Processor,M62439SP System Control Microcomputer, IX0301AW AM Input/Output Expander,BU2092F AC Reset,KIA7042AP BL Power Amp.,STK4113E TRANSISTORS Q1 Q51 Q52 Q103~106 Q107,108 Q109 Q110,111 Q113,114 Q121,122 Q124 Q126 Q128 Q302 Q343 Q344 Q601~604 Q702 Q703 Q704 Q705~707 Q801 VSKTA1266GR-1 VSKRC102M//-1 VSKTC3203Y/-1 VSKTC3200GR-1 VSKTC3199GR-1 VS2SA1318//-1 VSKRC104M//-1 VSKTC3199GR-1 VSKTC3199GR-1 VS2SA1015GR-1 VSKRC104M//-1 VSKTC3203Y/-1 VS2SC535-C/-1 VSKRA109M//-1 VSKRA102M//-1 VSKTC3199GR-1 VSKTA1273Y/-1 VSKTA1271Y/-1 VSKRC102M//-1 VSKTC3199GR-1 VHIAN78L05/-1 J J J J J J J J J J J J J J J J J J J J J AB AC AC AC AB AC AC AB AB AB AC AC AC AC AC AB AE AC AC AB AE Q802 Q803 Q850 Q851 Q852 Q853 Q901~904 Q905 Q907~909 Q910,911 VSKTC3199GR-1 VSKTA1274Y/-1 VSKTD2058Y/-1 VHIKIA7812P-1 VHIKIA7806P-1 VHIKIA78L05-1 VSKTC3199GR-1 VSKRC107M//-1 VSKTC3199GR-1 VSKRC107M//-1 J J J J J J J J J J AB AE AE AG AF AB AC AB AC Silicon,PNP,KTA1266 GR Digital,NPN,KRC102 M Silicon,NPN,KTC3203 Y Silicon,NPN,KTC3200 GR Silicon,NPN,KTC3199 GR Silicon,PNP,2SA1318 Digital,NPN,KRC104 M Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,PNP,2SA1015 GR Digital,NPN,KRC104 M Silicon,NPN,KTC3203 Y Silicon,NPN,2SC535 C Digital,PNP,KRA109 M Digital,PNP,KRA102 M Silicon,NPN,KTC3199 GR Silicon,PNP,KTA1273 Y Silicon,PNP,KTA1271 Y Digital,NPN,KRC102 M Silicon,NPN,KTC3199 GR Constant Voltage Regulator, AN78L05 Silicon,NPN,KTC3199 GR Silicon,PNP,KTA1274 Y Silicon,NPN,KTD2058 Y Voltage Regulator,KIA7812P Voltage Regulator,KIA7806P Voltage Regulator,KIA78L05 Silicon,NPN,KTC3199 GR Digital,NPN,KRC107 M Silicon,NPN,KTC3199 GR Digital,NPN,KRC107 M ! D1 D81,82 D91~93 D101,102 D301~305 D342 D551 D554~556 D601,602 D703 D705 D714~720 D801 D802~805 D806~808 D809 D810 D811~817 D850~853 D901,902 D903,904 D905,906 D907~913 DESCRIPTION J J J J J J J J J J J J J J J J J J J J J J J AB AC AC AC AC AC AB AC AB AC AC AC AC AG AK AD AC AC AB AC AA AB AC LED,Green,L1154GT4 LED,Orange,SLI342YCB LED,Yellow,SLI342DCB LED,Red,SLI342UCB LED,Orange,SLI342UCB LED,Yellow,SLI342YCB LED,Green,L1154GT4 LED,Yellow,SLI342YCJ LED,Yellow,SLI325YC LED,Yellow,SLI342YCE LED,Yellow,SLI342YCJ LED,Red,SLI342UCJ LED,Yellow,SLI342YCJ Silicon,SVC211C,Variable Cap Variable Capacitance,SVC348S Zener,5.6V,MTZJ5.6B Zener,5.1V,MTZJ5.1B Zener,6.2V,MTZJ6.2C Zener,2.4V,MTZJ2.4B Zener,30V,MTZJ30C Zener,6.2V,MTZJ6.2A Zener,8.2V,MTZJ8.2C Zener,13V,MTZJ13B J J J AE Band Pass Filter AD FM IF,10.7 MHz AE AM IF RCILI0017AWZZ RCILA0052AWZZ RCILB0058AWZZ RCILI0015AWZZ RCILI0016AWZZ RTRNP0245AWZZ RTRNP0239AWZZ J J J J J J J AB AE AC AE AC BM AP FM IF AM Antenna OSC,AM AM IF FM Detection Power Power VP-XHR82K0000 VP-DH2R2K0000 VP-DH101K0000 VP-MK331K0000 RCILR0029AWZZ RCILB0060AWZZ VP-DH101K0000 VP-DH2R2K0000 VP-DH101K0000 VP-DH101K0000 RCILZ0137AFZZ J J J J J J J J J J J AC AB AB AB AA AC AB AB AB AB AA 0.82 µH 2.2 mmH,Peaking 100 µH,Choke 330 µH,Choke FM RF OSC,FM 100 µH,Choke 2.2 mmH,Peaking 100 µH,Choke 100 µH,Choke 0.29 µH J AC 6.8 kohms (B),Semi-VR [VCO] PARTS CODE LED701 LED702 LED703 LED704 LED705 LED706 LED707 LED716,717 LED718 LED719,720 LED721 LED722 LED723,724 VD302,303 VD331 ZD61 ZD351 ZD551 ZD601,602 ZD801 ZD802 ZD901,902 ZD951 VHPL1154GT4-1 VHPSLI342YCB1 VHPSLI342DCB1 VHPSLI342UCB1 VHPSLI342DCB1 VHPSLI342YCB1 VHPL1154GT4-1 VHPSLI342YCJ1 VHPSLI325YC-1 VHPSLI342YCE1 VHPSLI342YCJ1 VHPSLI342UCJ1 VHPSLI342YCJ1 VHCSVC211C/-1 VHCSVC348S/-1 VHEMTZJ5R6B-1 VHEMTZJ5R1B-1 VHEMTZJ6R2C-1 VHEMTZJ2R4B-1 VHEMTZJ300C-1 VHEMTZJ6R2A-1 VHEMTZJ8R2C-1 VHEMTZJ130B-1 RFILR0008AWZZ RFILF0124AFZZ 92LFILTA1768A FILTERS BF301 CF301 CF351 TRANSFORMERS ! ! T301 T331 T333 T351 T352 T801 T802 COILS L61 L99 L103 L104 L302 L303 L343 L601 L702 L802 L901,902 VARIABLE RESISTOR VR351 DIODES PRICE RANK NO. RVR-M0025AWZZ VIBRATORS VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1SS133//-1 VHD1N4004S/-1 VHD1SS133//-1 VHDTS6B04GM-1 VHDBR102J02-1 VHD1N4004S/-1 VHD1SS133//-1 VHD1N4004S/-1 VHD1SS133//-1 VHD1N5402M/-1 VHD1SS133//-1 J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AA AA AA AA AA AB AA AP AM AB AA AB AA AE AA Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1SS133 Silicon,1N4004S Silicon,1SS133 Silicon,TS6B04GM Silicon,BR102J02 Silicon,1N4004S Silicon,1SS133 Silicon,1N4004S Silicon,1SS133 Silicon,1N5402M Silicon,1SS133 X352 XL1 XL701 RCRSP0002AWZZ J RCRSP0005AWZZ J RCRSP0003AWZZ J AH Crystal,4.5 MHz AF Crystal,16.934 MHz AH Crystal,4.19 MHz CAPACITORS C1 C2 C3 C4 C5,6 C7 C8 C9 C10 C11,12 C13 C14,15 C16 C17 C18 C19 –1– VCEAZA1CW476M VCKYTV1HB103K VCEAZA1HW105M VCEAZA1HW104M VCTYPA1CX333K VCEAZA1HW104M VCTYPA1CX683K VCTYPA1CX473K VCCSTV1HL181J VCTYPA1CX104K VCKYTV1HB331K VCKYTV1HB103K VCKYTV1HB472K VCKYTV1HB102K VCEAZA1HW474M VCEAZA1HW105M J J J J J J J J J J J J J J J J AB AA AB AB AA AB AA AA AA AB AA AA AA AA AB AB 47 µF,16V,Electrolytic 0.01 µF,50V 1 µF,50V,Electrolytic 0.1 µF,50V,Electrolytic 0.033 µF,16V 0.1 µF,50V,Electrolytic 0.068 µF,16V 0.047 µF,16V 180 pF,50V 0.1 µF,16V 330 pF,50V 0.01 µF,50V 0.0047 µF,50V 0.001 µF,50V 0.47 µF,50V,Electrolytic 1 µF,50V,Electrolytic CD-C662 NO. C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39,40 C41 C42 C43 C44~47 C48 C49 C50 C51,52 C54 C55 C56 C57 C71,72 C73,74 C75 C76 C77 C82 C83 C98 C99 C101,102 C103 C105 C106 C107,108 C109 C111~114 C115,116 C117,118 C119,120 C121,122 C127 C128 C129,130 C131,132 C133,134 C135,136 C139,140 C141,142 C145 C146 C150 C151 C152 C153 C154 C155,156 C302 C303 C304 C305 C306 C307,308 C309 C310 C311 C312 C313 C314 C316 C317 PARTS CODE VCEAZA1CW476M VCKYTV1HB332K VCCSPA1HL221J VCKYTV1HB272K VCCSTV1HL2R2C VCCSTV1HL270J VCTYPA1CX333K VCKYTV1HB102K VCTYPA1CX104K VCEAZA1HW475M VCEAZA1HW104M VCEAZA0JW227M VCKYTV1HB103K VCEAZA1HW474M VCEAZA1HW334M VCEAZA1HW105M VCEAZA1CW107M VCKZPA1HF223Z VCKYTV1HB103K VCKZPA1HF473K VCCSPA1HL120J VCCSPA1HL150J VCEAZA0JW337M VCCCTV1HH101J VCCSPA1HL101J VCCCTV1HH101J VCKYTV1EF223Z VCEAZA1CW107M VCKYTV1HB102K VCEAZA1CW107M VCKYTV1EF223Z VCKYBT1HB102K VCEAZA1HW106M VCKYTV1HB221K VCKYTV1HB102K VCKZPA1HF223Z VCEAZA1CW107M VCEAZA1CW107M VCTYBT1EF223Z VCKZPA1HF223Z VCEAZA1AW107M VCKYMN1HB102K VCKYPA1HB103K VCKYBT1HB181K VCKYMN1HB181K VCKYMN1HB102K VCKZPA1HF473Z VCKYMN1HB331K VCEAZA1EW476M VCTYPA1EX333K VCKYMN1HB561K VCEAZA1HW105M VCTYMN1EF223Z VCEAZA1HW335M VCKYMN1HB471K VCKYMN1HB102K VCEAZA1EW226M VCTYPA1CX823K VCTYMN1CX332K VCEAZA1HW105M VCEAZA1EW226M VCEAZA1CW227M VCQPKA2AA392J VCQYKA1HM273K VCEAZA1EW476M VCEAZA1CW107M VCEAZA1CW476M VCEAZA1HW335M VCCCMN1HH100J VCTYMN1CY103N VCCCMN1HH4R7C VCCCMN1HH150J VCCCMN1HH180J VCTYMN1CX472K VCCUMN1HJ4R7D VCKYMN1HB102K VCTYMN1EF223Z VCKYMN1HB102K VCTYMN1EF223Z VCEAZA1CW106M VCKYBT1HB101K VCCUMN1HJ3R9K J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J PRICE RANK DESCRIPTION AB AA AA AA AB AA AA AA AB AB AB AC AA AB AB AB AC AA AA AA AA AA AC AA AA AA AA AC AA AC AA AA AB AA AA AA AC AC AA AA AB AA AA AA AA AA AA AA AB AA AA AB AA AB AA AA AB AB AA AB AB AC AB AB AB AC AB AB AA AA AA AA AA AA AA AA AA AA AA AC AA AA 47 µF,16V,Electrolytic 0.0033 µF,50V 220 pF,50V 0.0027 µF,50V 2.2 pF,50V 27 pF,50V 0.033 µF,16V 0.001 µF,50V 0.1 µF,16V 4.7 µF,50V,Electrolytic 0.1 µF,50V,Electrolytic 220 µF,6.3V,Electrolytic 0.01 µF,50V 0.47 µF,50V,Electrolytic 0.33 µF,50V,Electrolytic 1 µF,50V,Electrolytic 100 µF,16V,Electrolytic 0.022 µF,50V 0.01 µF,50V 0.047 µF,50V 12 pF,50V 15 pF,50V 330 µF,6.3V,Electrolytic 100 pF (CH),50V 100 pF,50V 100 pF (CH),50V 0.022 µF,25V 100 µF,16V,Electrolytic 0.001 µF,50V 100 µF,16V,Electrolytic 0.022 µF,25V 0.001 µF,50V 10 µF,50V,Electrolytic 220 pF,50V 0.001 µF,50V 0.022 µF,50V 100 µF,16V,Electrolytic 100 µF,16V,Electrolytic 0.022 µF,25V 0.022 µF,50V 100 µF,10V,Electrolytic 0.001 µF,50V 0.01 µF,50V 180 pF,50V 180 pF,50V 0.001 µF,50V 0.047 µF,50V 330 pF,50V 47 µF,25V,Electrolytic 0.033 µF,25V 560 pF,50V 1 µF,50V,Electrolytic 0.022 µF,25V 3.3 µF,50V,Electrolytic 470 pF,50V 0.001 µF,50V 22 µF,25V,Electrolytic 0.082 µF,16V 0.0033 µF,16V 1 µF,50V,Electrolytic 22 µF,25V,Electrolytic 220 µF,16V,Electrolytic 0.0039 µF,100V,Polypropylene 0.027 µF,50V,Mylar 47 µF,25V,Electrolytic 100 µF,16V,Electrolytic 47 µF,16V,Electrolytic 3.3 µF,50V,Electrolytic 10 pF (CH),50V 0.01 µF,16V 4.7 pF (CH),50V 15 pF (CH),50V 18 pF (CH),50V 0.0047 µF,16V 4.7 pF (UJ),50V 0.001 µF,50V 0.022 µF,25V 0.001 µF,50V 0.022 µF,25V 10 µF,16V,Electrolytic 100 pF,50V 3.9 pF (UJ),50V NO. –2– C318 C319 C320 C330 C331 C332,333 C334 C335 C337 C338 C349 C350 C351 C353 C354 C355~357 C358 C359,360 C361 C363,364 C365~367 C369 C381 C382 C383 C392 C393 C395 C551 C553 C555,556 C557 C559 C561~563 C566~568 C569 C601~606 C611,612 C613~615 C616 C617 C618,619 C620~622 C623~626 C627 C628 C629 C630 C631,632 C634,635 C641 C673 C702 C703,704 C705 C706 C707 C708 C709 C710 C711 C712 C713,714 C715 C716 C717 C718 C719 C720 C722 C723 C801 C802 C803 C804 C805 C809,810 C811,812 C813,814 C815,816 C817 C818,819 PRICE RANK PARTS CODE VCCCMN1HH220J VCTYMN1EF223Z VCKYPA1HB102K VCCUMN1HJ8R2D VCKZPA1HF473Z VCTYMN1EF223Z VCCUMN1HJ220J VCCSPA1HL561J VCEAZA1HW106M VCKYMN1HB101K VCTYMN1EF223Z VCEAZA1AW227M VCTYMN1CX222K VCTYMN0JY183M VCKYMN1HB221K VCEAZA1HW335M CPU100V1500PJ VCTYMN1EF223Z VCEAZA1CW226M VCTYPA1EX153K VCEAZA1HW105M VCEAZA1CW476M VCCCMN1HH120J VCCCMN1HH150J VCTYMN1EF223Z VCKYMN1HB102K VCEAZA1HW105M VCKYMN1HB102K VCKYMN1HB271K VCTYMN1CX272K VCTYMN1CX682K VCKYMN1HB271K VCTYMN1CX272K VCTYMN1EF223Z VCEAZA1HW225M VCTYMN1EF223Z VCEAZA1HW475M VCTYPA1EX333K VCFYDA1HA224J VCCSMN1HL4R7K VCEAZA1HW106M VCTYMN1EF223Z VCEAZA1HW106M VCKYMN1HB102K VCEAZA1EW226M VCFYDA1HA224J VCEAZA1EW226M VCKYMN1HB102K VCKYMN1HB391K VCTYMN1CX822K VCKYPA1HB102K VCKYPA1HB103K VCEAZA1HW105M VCKYMN1HB102K RC-EZD476AF1C VCEAZA1HW105M VCCSMN1HL150J VCCSMN1HL180J VCTYBT1EF223Z VCEAZA1AW227M VCTYMN1CY103N VCEAZA1HW335M VCTYMN1EF223Z RC-EZD476AF1C VCEAZA1EW476M VCTYBT1EF223Z VCEAZA1EW476M VCTYMN1EF223Z VCEAZA1HW476M RC-EZD106AF1H VCEAZA1HW104M RC-KZ001LAWZZ VCQYKA1HM473J VCEAZA1EW477M VCEAZA1CW106M VCEAZV0JW228M VCFYDA1HA224J VCQYKA2AM224K VCQYKA1HM473J VCEAZA1HW107M VCEAZA1HW227M VCEAZA1HW476M J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AB AA AA AC AA AA AA AB AC AA AC AA AB AB AA AA AA AA AB AA AA AA AA AA AA AA AB AA AB AA AB AA AB AA AB AA AB AB AB AA AA AA AA AA AB AA AC AB AA AA AA AC AA AB AA AC AB AA AB AA AB AB AB AB AB AD AC AB AB AC AC AB DESCRIPTION 22 pF (CH),50V 0.022 µF,25V 0.001 µF,50V 8.2 pF (UJ),50V 0.047 µF,50V 0.022 µF,25V 22 pF (UJ),50V 560 pF,50V 10 µF,50V,Electrolytic 100 pF,50V 0.022 µF,25V 220 µF,10V,Electrolytic 0.0022 µF,16V 0.018 µF,6.3V 220 pF,50V 3.3 µF,50V,Electrolytic 0.0015 µF,100V, Polypropylene 0.022 µF,25V 22 µF,16V,Electrolytic 0.015 µF,25V 1 µF,50V,Electrolytic 47 µF,16V,Electrolytic 12 pF (CH),50V 15 pF (CH),50V 0.022 µF,25V 0.001 µF,50V 1 µF,50V,Electrolytic 0.001 µF,50V 270 pF,50V 0.0027 µF,16V 0.0068 µF,16V 270 pF,50V 0.0027 µF,16V 0.022 µF,25V 2.2 µF,50V,Electrolytic 0.022 µF,25V 4.7 µF,50V,Electrolytic 0.033 µF,25V 0.22 µF,50V,Polyester 4.7 pF,50V 10 µF,50V,Electrolytic 0.022 µF,25V 10 µF,50V,Electrolytic 0.001 µF,50V 22 µF,25V,Electrolytic 0.22 µF,50V,Polyester 22 µF,25V,Electrolytic 0.001 µF,50V 390 pF,50V 0.0082 µF,16V 0.001 µF,50V 0.01 µF,50V 1 µF,50V,Electrolytic 0.001 µF,50V 47 µF,16V,Electrolytic 1 µF,50V,Electrolytic 15 pF,50V 18 pF,50V 0.022 µF,25V 220 µF,10V,Electrolytic 0.01 µF,16V 3.3 µF,50V,Electrolytic 0.022 µF,25V 47 µF,16V,Electrolytic 47 µF,25V,Electrolytic 0.022 µF,25V 47 µF,25V,Electrolytic 0.022 µF,25V 47 µF,50V,Electrolytic 10 µF,50V,Electrolytic 0.1 µF,50V,Electrolytic 0.0047 µF,250VAC,Ceramic 0.047 µF,50V,Mylar 470 µF,25V,Electrolytic 10 µF,16V,Electrolytic 2200 µF,6.3V,Electrolytic 0.22 µF,50V,Polyester 0.22 µF,100V,Mylar 0.047 µF,50V,Mylar 100 µF,50V,Electrolytic 220 µF,50V,Electrolytic 47 µF,50V,Electrolytic CD-C662 NO. C820 C850 C851 C852,853 C854 C855,856 C857 C858,859 C860 C901,902 C903,904 C911,912 C913,914 C915,916 C917,918 C919,920 C921,922 C923,924 C925 C929,930 C943 C945 C951 C952 C955 C956,957 PRICE RANK PARTS CODE VCEAZA1VW107M VCEAZW1EW338M VCEAZA1EW226M VCQYKA1HM473K VCEAZA1EW476M VCQYKA1HM104K VCEAZA1EW476M VCQYKA1HM104K VCEAZA1EW476M RC-EZ0029AWZZ VCEAEA1VW478M VCCSPA1HL470J VCCSPA1HL330J VCEAZA1HW476M VCEAZA1HW225M VCEAZV2AW107M VCEAZA1HW476M VCQYKA1HM223J VCEAZA1HW476M VCQYKA1HM104J VCEAZA1HW106M VCEAZA1EW476M VCQYKA1HM223J VCEAZA1EW227M VCEAZA1EW226M VCEAZV2AW476M J J J J J J J J J J J J J J J J J J J J J J J J J J AC AG AB AB AB AB AB AB AB AN J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AB AB AB AB AB AC AB AB AB AC AB DESCRIPTION 100 µF,35V,Electrolytic 3300 µF,25V,Electrolytic 22 µF,25V,Electrolytic 0.047 µF,50V,Mylar 47 µF,25V,Electrolytic 0.1 µF,50V,Mylar 47 µF,25V,Electrolytic 0.1 µF,50V,Mylar 47 µF,25V,Electrolytic 3300 µF,71V,Electrolytic 4700 µF,35V,Electrolytic 47 pF,50V 33 pF,50V 47 µF,50V,Electrolytic 2.2 µF,50V,Electrolytic 100 µF,100V,Electrolytic 47 µF,50V,Electrolytic 0.022 µF,50V,Mylar 47 µF,50V,Electrolytic 0.1 µF,50V,Mylar 10 µF,50V,Electrolytic 47 µF,25V,Electrolytic 0.022 µF,50V,Mylar 220 µF,25V,Electrolytic 22 µF,25V,Electrolytic 47 µF,100V,Electrolytic RESISTORS R1 R2 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35,36 R37 R38 R39 R40 R41,42 R43 R44 R45 R46 R47 R50 R51 R52 R53 R54 R55 R56 R57 R58~60 R61~63 R64 VRD-MN2BD000C VRS-TV2AB000J VRS-TV2AB220J VRD-ST2CD102J VRS-TV2AB153J VRS-TV2AB104J VRS-TV2AB222J VRD-ST2CD682J VRD-ST2CD101J VRS-TV2AB102J VRS-TV2AB273J VRS-TV2AB123J VRS-TV2AB332J VRS-TV2AB333J VRS-TV2AB153J VRD-ST2CD102J VRS-TV2AB102J VRS-TV2AB152J VRS-TV2AB821J VRS-TV2AB103J VRS-TV2AB473J VRS-TV2AB152J VRS-TV2AB823J VRS-TV2AB393J VRS-TV2AB103J VRS-TV2AB563J VRS-TV2AB682J VRS-TV2AB122J VRS-TV2AB103J VRS-TV2AB122J VRS-TV2AB332J VRS-TV2AB224J VRD-ST2CD823J VRS-TV2AB471J VRD-ST2CD102J VRS-TV2AB562J VRS-TV2AB473J VRS-TV2AB563J VRS-TV2AB333J VRS-TV2AB472J VRS-TV2AB561J VRD-ST2CD103J VRS-TV2AB681J VRD-ST2CD335J VRS-TV2AB273J VRS-TV2AB122J VRD-ST2CD331J VRD-ST2CD101J VRS-TV2AB223J VRD-ST2CD102J VRS-TV2AB102J VRD-ST2CD102J VRS-TV2AB220J 0 ohm,Jumper,ø1.4×3.5mm,Ivory 0 ohm,Jumper,1.25×2mm,Green 22 ohms,1/10W 1 kohm,1/6W 15 kohms,1/10W 100 kohm,1/10W 2.2 kohms,1/10W 6.8 kohms,1/6W 100 ohm,1/6W 1 kohm,1/10W 27 kohms,1/10W 12 kohms,1/10W 3.3 kohms,1/10W 33 kohms,1/10W 15 kohms,1/10W 1 kohm,1/6W 1 kohm,1/10W 1.5 kohms,1/10W 820 ohms,1/10W 10 kohm,1/10W 47 kohms,1/10W 1.5 kohms,1/10W 82 kohms,1/10W 39 kohms,1/10W 10 kohm,1/10W 56 kohms,1/10W 6.8 kohms,1/10W 1.2 kohms,1/10W 10 kohm,1/10W 1.2 kohms,1/10W 3.3 kohms,1/10W 220 kohms,1/10W 82 kohms,1/6W 470 ohms,1/10W 1 kohm,1/6W 5.6 kohms,1/10W 47 kohms,1/10W 56 kohms,1/10W 33 kohms,1/10W 4.7 kohms,1/10W 560 ohms,1/10W 10 kohm,1/6W 680 ohms,1/10W 3.3 Mohms,1/6W 27 kohms,1/10W 1.2 kohms,1/10W 330 ohms,1/6W 100 ohm,1/6W 22 kohms,1/10W 1 kohm,1/6W 1 kohm,1/10W 1 kohm,1/6W 22 ohms,1/10W NO. R65 R66 R71,72 R73,74 R80,81 R82,83 R84 R88,89 R90 R91 R93 R101 R102 R103,104 R105,106 R107,108 R109,110 R111,112 R113,114 R115 R117,118 R119,120 R121,122 R123,124 R125,126 R131,132 R134 R135,136 R137 R138 R139,140 R141,142 R145,146 R153,154 R155 R156 R157 R158 R160 R162 R164 R166 R167 R168 R169 R170 R171,172 R173,174 R175 R301 R302 R303 R305 R306 R311 R312 R313 R314 R316 R317 R320 R321 R323 R347 R348 R350 R352 R356 R359 R360 R361 R362 R365 R366,367 R369 R371~374 R375 R379 R380 R381 R551 R553 –3– PRICE RANK PARTS CODE VRD-ST2CD102J VRS-TV2AB221J VRD-ST2CD272J VRS-TV2AB104J VRD-ST2CD102J VRS-TV2AB122J VRD-ST2CD222J VRD-ST2CD122J VRD-ST2CD221J VRD-ST2CD102J VRS-TV2AB221J VRD-MN2BD102J VRD-ST2CD102J VRD-MN2BD222J VRD-MN2BD332J VRD-MN2BD473J VRD-MN2BD472J VRD-ST2CD103J VRD-MN2BD103J VRD-MN2BD472J VRD-MN2BD102J VRD-ST2CD560J VRD-MN2BD104J VRD-MN2BD392J VRD-MN2BD562J VRD-MN2BD333J VRD-MN2BD683J VRD-MN2BD183J VRD-MN2BD682J VRD-ST2CD682J VRD-MN2BD561J VRD-MN2BD560J VRD-MN2BD103J VRD-MN2BD103J VRD-ST2EE151J VRD-ST2CD224J VRD-MN2BD224J VRD-ST2EE221J VRD-ST2EE151J VRD-MN2BD473J VRD-MN2BD472J VRD-MN2BD473J VRD-MN2BD104J VRD-MN2BD120J VRD-MN2BD182J VRD-ST2CD182J VRD-MN2BD224J VRD-MN2BD562J VRD-ST2CD102J VRD-MN2BD333J VRD-ST2CD220J VRD-MN2BD104J VRD-MN2BD820J VRD-MN2BD100J VRD-MN2BD224J VRD-MN2BD681J VRD-MN2BD470J VRD-MN2BD103J VRD-MN2BD472J VRD-ST2EE821J VRD-ST2CD103J VRD-MN2BD121J VRD-MN2BD683J VRD-MN2BD392J VRD-MN2BD333J VRD-ST2CD473J VRD-MN2BD153J VRD-ST2CD103J VRD-MN2BD473J VRD-MN2BD152J VRD-MN2BD103J VRD-ST2EE391J VRD-ST2EE681J VRD-ST2CD821J VRD-MN2BD222J VRD-MN2BD102J VRD-ST2CD122J VRD-MN2BD222J VRD-MN2BD152J VRD-ST2CD103J VRD-MN2BD103J VRD-ST2CD123J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA DESCRIPTION 1 kohm,1/6W 220 ohms,1/10W 2.7 kohms,1/6W 100 kohm,1/10W 1 kohm,1/6W 1.2 kohms,1/10W 2.2 kohms,1/6W 1.2 kohms,1/6W 220 ohms,1/6W 1 kohm,1/6W 220 ohms,1/10W 1 kohm,1/8W 1 kohm,1/6W 2.2 kohms,1/8W 3.3 kohms,1/8W 47 kohms,1/8W 4.7 kohms,1/8W 10 kohm,1/6W 10 kohm,1/8W 4.7 kohms,1/8W 1 kohm,1/8W 56 ohms,1/6W 100 kohm,1/8W 3.9 kohms,1/8W 5.6 kohms,1/8W 33 kohms,1/8W 68 kohms,1/8W 18 kohms,1/8W 6.8 kohms,1/8W 6.8 kohms,1/6W 560 ohms,1/8W 56 ohms,1/8W 10 kohm,1/8W 10 kohm,1/8W 150 ohms,1/4W 220 kohms,1/6W 220 kohms,1/8W 220 ohms,1/4W 150 ohms,1/4W 47 kohms,1/8W 4.7 kohms,1/8W 47 kohms,1/8W 100 kohm,1/8W 12 ohms,1/8W 1.8 kohms,1/8W 1.8 kohms,1/6W 220 kohms,1/8W 5.6 kohms,1/8W 1 kohm,1/6W 33 kohms,1/8W 22 ohms,1/6W 100 kohm,1/8W 82 ohms,1/8W 10 ohm,1/8W 220 kohms,1/8W 680 ohms,1/8W 47 ohms,1/8W 10 kohm,1/8W 4.7 kohms,1/8W 820 ohms,1/4W 10 kohm,1/6W 120 ohms,1/8W 68 kohms,1/8W 3.9 kohms,1/8W 33 kohms,1/8W 47 kohms,1/6W 15 kohms,1/8W 10 kohm,1/6W 47 kohms,1/8W 1.5 kohms,1/8W 10 kohm,1/8W 390 ohms,1/4W 680 ohms,1/4W 820 ohms,1/6W 2.2 kohms,1/8W 1 kohm,1/8W 1.2 kohms,1/6W 2.2 kohms,1/8W 1.5 kohms,1/8W 10 kohm,1/6W 10 kohm,1/8W 12 kohms,1/6W CD-C662 NO. R555 R556 R558 R560 R561 R562 R564 R566 R567 R568 R570 R572 R573 R574,575 R578~580 R601~608 R609 R610 R611 R612 R613,614 R615,616 R617~620 R623 R624 R625 R626 R628 R629,630 R631,632 R633,634 R635,636 R637,638 R639 R640 R641 R642 R650,651 R652,653 R701~703 R705~708 R709~711 R712 R713~715 R716 R717 R719,720 R721~723 R724 R726~729 R730~732 R733,734 R735 R736,737 R738 R739 R740~743 R744,745 R747,748 R749,750 R751 R752~754 R755,756 R757 R758 R759,760 R762~778 R780 R781 R782~785 R786 R787 R795 R797 R798 R799 R801 R802 R803 R804 R805 R850 PRICE RANK PARTS CODE VRD-ST2CD563J VRD-MN2BD333J VRD-ST2CD683J VRD-ST2CD474J VRD-ST2CD153J VRD-MN2BD394J VRD-MN2BD394J VRD-MN2BD225J VRD-MN2BD274J VRD-MN2BD224J VRD-MN2BD224J VRD-MN2BD225J VRD-MN2BD564J VRD-ST2EE331J VRD-MN2BD104J VRD-MN2BD152J VRD-MN2BD222J VRD-MN2BD103J VRD-MN2BD331J VRD-MN2BD153J VRD-MN2BD103J VRD-MN2BD472J VRD-MN2BD222J VRD-ST2CD562J VRD-MN2BD331J VRD-MN2BD223J VRD-MN2BD222J VRD-MN2BD223J VRD-RT2HD561J VRD-MN2BD822J VRD-MN2BD393J VRD-MN2BD331J VRD-ST2CD224J VRD-MN2BD223J VRD-MN2BD473J VRD-MN2BD223J VRD-MN2BD473J VRD-ST2CD102J VRD-MN2BD104J VRD-ST2CD102J VRD-ST2CD102J VRD-MN2BD102J VRD-MN2BD223J VRD-MN2BD102J VRD-ST2CD330J VRD-MN2BD103J VRD-MN2BD103J VRD-MN2BD104J VRD-MN2BD103J VRD-ST2CD103J VRD-MN2BD102J VRD-ST2CD222J VRD-ST2CD182J VRD-MN2BD102J VRD-ST2CD102J VRD-MN2BD103J VRD-MN2BD102J VRD-ST2CD102J VRD-ST2CD103J VRD-MN2BD103J VRD-ST2CD332J VRD-ST2CD103J VRD-MN2BD103J VRD-ST2CD103J VRD-MN2BD122J VRD-MN2BD103J VRD-ST2CD102J VRD-ST2CD103J VRD-MN2BD821J VRD-ST2CD102J VRD-MN2BD102J VRD-ST2CD102J VRD-MN2BD473J VRD-MN2BD104J VRD-MN2BD101J VRD-MN2BD472J VRD-ST2CD101J VRD-ST2CD222J VRD-ST2CD123J VRD-ST2CD102J VRD-ST2EE100J VRD-RT2HD3R3J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA DESCRIPTION NO. 56 kohms,1/6W 33 kohms,1/8W 68 kohms,1/6W 470 kohms,1/6W 15 kohms,1/6W 390 kohms,1/8W 390 kohms,1/8W 2.2 Mohms,1/8W 270 kohms,1/8W 220 kohms,1/8W 220 kohms,1/8W 2.2 Mohms,1/8W 560 kohms,1/8W 330 ohms,1/4W 100 kohm,1/8W 1.5 kohms,1/8W 2.2 kohms,1/8W 10 kohm,1/8W 330 ohms,1/8W 15 kohms,1/8W 10 kohm,1/8W 4.7 kohms,1/8W 2.2 kohms,1/8W 5.6 kohms,1/6W 330 ohms,1/8W 22 kohms,1/8W 2.2 kohms,1/8W 22 kohms,1/8W 560 ohms,1/2W 8.2 kohms,1/8W 39 kohms,1/8W 330 ohms,1/8W 220 kohms,1/6W 22 kohms,1/8W 47 kohms,1/8W 22 kohms,1/8W 47 kohms,1/8W 1 kohm,1/6W 100 kohm,1/8W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/8W 22 kohms,1/8W 1 kohm,1/8W 33 ohms,1/6W 10 kohm,1/8W 10 kohm,1/8W 100 kohm,1/8W 10 kohm,1/8W 10 kohm,1/6W 1 kohm,1/8W 2.2 kohms,1/6W 1.8 kohms,1/6W 1 kohm,1/8W 1 kohm,1/6W 10 kohm,1/8W 1 kohm,1/8W 1 kohm,1/6W 10 kohm,1/6W 10 kohm,1/8W 3.3 kohms,1/6W 10 kohm,1/6W 10 kohm,1/8W 10 kohm,1/6W 1.2 kohms,1/8W 10 kohm,1/8W 1 kohm,1/6W 10 kohm,1/6W 820 ohms,1/8W 1 kohm,1/6W 1 kohm,1/8W 1 kohm,1/6W 47 kohms,1/8W 100 kohm,1/8W 100 ohm,1/8W 4.7 kohms,1/8W 100 ohm,1/6W 2.2 kohms,1/6W 12 kohms,1/6W 1 kohm,1/6W 10 ohm,1/4W 3.3 ohms,1/2W ! R851 R852,853 R854 R855 R901,902 R903,904 R905,906 R907,908 R909,910 R911 R912,913 R915,916 R917,918 R919,920 R921,922 R923 R925~928 R929,930 R931,932 R933,934 R935,936 R937 R938 R939 R941,942 R943 R953,954 R955,956 R957 R958 R959 R960 R961,962 RD01 RD02 RD03 RD04 RD05 RD06 RD07 RD09 RD10 RD11 RD12 RD13 RD14 RD15 RD16 RD21 RD22 RD23 RD24 RD25 RD26 RD27 RD28 RS701~703 RS704,705 RS706 RS707 RS711 RS712 PRICE RANK PARTS CODE VRD-ST2CD330J VRD-ST2CD223J VRD-ST2CD103J VRD-RT2HD3R3J VRD-ST2CD102J VRD-ST2CD563J VRD-ST2CD102J VRD-ST2CD391J VRD-ST2CD563J VRD-ST2CD333J VRG-ST2EC101J VRD-ST2CD392J VRN-VV3LAR10J VRD-ST2CD152J VRD-ST2CD472J VRD-ST2CD563J VRD-RT2HD100J VRD-ST2CD563J VRD-RT2HD4R7J VRD-ST2CD472J VRD-RT2HD221J VRD-ST2CD153J VRD-ST2CD683J VRD-ST2CD392J VRS-VV3DA561J VRS-VV3DA681J VRD-ST2CD332J VRD-ST2CD102J VRD-ST2CD104J VRD-ST2CD681J VRD-ST2CD822J VRD-ST2CD103J VRD-ST2CD393J VRD-ST2CD821J VRD-MN2BD122J VRD-MN2BD152J VRD-MN2BD182J VRD-MN2BD222J VRD-MN2BD332J VRD-ST2CD392J VRD-MN2BD682J VRD-MN2BD821J VRD-MN2BD122J VRD-MN2BD152J VRD-ST2CD182J VRD-ST2CD222J VRD-MN2BD332J VRD-ST2CD392J VRD-MN2BD821J VRD-MN2BD122J VRD-ST2CD152J VRD-ST2CD182J VRD-MN2BD222J VRD-ST2CD332J VRD-MN2BD392J VRD-MN2BD682J VRD-MN2BD102J VRD-ST2CD102J VRD-MN2BD102J VRD-ST2CD102J VRD-ST2CD152J VRD-MN2BD122J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J AA AA AA AA AA AA AA AA AA AA AB AA DESCRIPTION AA AA AA AA AA AA AA AA AA AA AA AC AC AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 33 ohms,1/6W 22 kohms,1/6W 10 kohm,1/6W 3.3 ohms,1/2W 1 kohm,1/6W 56 kohms,1/6W 1 kohm,1/6W 390 ohms,1/6W 56 kohms,1/6W 33 kohms,1/6W 100 ohm,1/4W,Fusible 3.9 kohms,1/6W 0.1 ohm,3W 1.5 kohms,1/6W 4.7 kohms,1/6W 56 kohms,1/6W 10 ohm,1/2W 56 kohms,1/6W 4.7 ohms,1/2W 4.7 kohms,1/6W 220 ohms,1/2W 15 kohms,1/6W 68 kohms,1/6W 3.9 kohms,1/6W 560 ohms,2W 680 ohms,2W 3.3 kohms,1/6W 1 kohm,1/6W 100 kohm,1/6W 680 ohms,1/6W 8.2 kohms,1/6W 10 kohm,1/6W 39 kohms,1/6W 820 ohms,1/6W 1.2 kohms,1/8W 1.5 kohms,1/8W 1.8 kohms,1/8W 2.2 kohms,1/8W 3.3 kohms,1/8W 3.9 kohms,1/6W 6.8 kohms,1/8W 820 ohms,1/8W 1.2 kohms,1/8W 1.5 kohms,1/8W 1.8 kohms,1/6W 2.2 kohms,1/6W 3.3 kohms,1/8W 3.9 kohms,1/6W 820 ohms,1/8W 1.2 kohms,1/8W 1.5 kohms,1/6W 1.8 kohms,1/6W 2.2 kohms,1/8W 3.3 kohms,1/6W 3.9 kohms,1/8W 6.8 kohms,1/8W 1 kohm,1/8W 1 kohm,1/6W 1 kohm,1/8W 1 kohm,1/6W 1.5 kohms,1/6W 1.2 kohms,1/8W AF AF AL AG AG AF AE AG AL AB AB AC AC AC AC AG AC Connector Ass’y,2Pin Connector Ass’y,6/6Pin Connector Ass’y,15/15Pin Connector Ass’y,3/3Pin Connector Ass’y,8/12Pin Connector Ass’y,6/6Pin Connector Ass’y,3/3Pin Connector Ass’y,8/8Pin Connector Ass’y,6/10/2Pin Plug,5Pin Plug,8Pin Plug,6Pin Plug,6Pin Plug,10Pin Plug,6Pin Plug,15Pin Plug,3/2Pin OTHER CIRCUITRY PARTS BI1B BI11/CNS11 BI12/CNS12 BI99/CNS99 BI702/CNSM1 BI704/CNS704 BI801/CNS801 BI802/CNS802 BIM5/CNS10/CNS5 CNP1 CNP2 CNP3 CNP3A CNP10 CNP11 CNP12 CNP99/BI1A –4– QCNWN1473AWZZ QCNWN1487AWZZ QCNWN1381AWZZ QCNWN1486AWZZ QCNWN1386AWZZ QCNWN1426AWZZ QCNWN1428AWZZ QCNWN1429AWZZ QCNWN1184AWZZ 92LCONE5P53253 QCNCM705HAFZZ 92LCONE6P53253 92LCONE6P53254 QCNCM705KAWZZ QCNCM704FAWZZ QCNCM704QAWZZ QCNCM704CAWZZ J J J J J J J J J J J J J J J J J CD-C662 NO. ! ! ! PRICE RANK PARTS CODE CNP101 CNP102 CNP301 CNP701 CNP704 CNP801 CNP802 CNP901 CNP903 CNPM1 CNPM2 CNS1A/B CNS2A/B CNS3A/B CNS101 CNS102 CNS701 CNS901 CNS903 F801 F804,805 F806 FFC701 FL701 FW703 FWM1 FWM2 IC99 92LCONE3P53253 J 92LCONE7P53253 J 92LCONE-3P5268 J QCNCWZG24AWZZ J QCNCM705FAFZZ J QCNCM035CAWZZ J QCNCM035HAWZZ J QCNCM010NAWZZ J 92LCONE2P53253 J QCNCM932MAFZZ J QCNCM030BAWZZ J QCNWN1181AWZZ J QCNWN1182AWZZ J QCNWN1183AWZZ J QCNWN1187AWZZ J QCNWN1188AWZZ J QCNCWZF24AWZZ J QCNCW010NAWZZ J QCNWN1452AWZZ J QFS-D502CSJNI J QFS-D502CSJNI J QFS-D202DSJNI J QCNWN1453AWZZ J VVKBJ685GNK-1 J QCNWN1427AWZZ J QCNWN1274AWZZ J QCNWN0338AWZZ J VHPGP1F32T/-1 J AB AC AC AE AB AB AB AC AB AE AB AK AH AG AG AM AE AC AC AC AC AD JK601 JK671 JOG701 LUG901 M1 M2 M3 QSOCJ0213AWZZ QJAKM0008AWZZ QSW-Z0007AWZZ QLUGP0001AWZZ 92LMTR1858CASY 92LMTR1854BASY 92LMTR3022AS1 J J J J J J J AE AF AC AS AP AU M901 MM1(260-7) PHM1 PIN103 RL801 RL901 RX701 SO901 SOLM1(260-8) SOLM2 SW1 SW2 92LMTR1810A RMOTV0006AWM1 VHPI31535CD-1 QLUGP0002AWZZ RRLYD0012AWZZ RRLYD0004AWZZ VHLN63H380A-1 QTANA0401AWZZ RPLU-0002AWZZ RPLU-0002AWZZ QSW-P0004AWZZ QSW-F0001AWZZ J J J J J J J J J J J J AK AR AG AB AM AP AK AG AH AH AE AD SW3 SW4 SW701 SW703 SW704 QSW-P0005AWZZ QSW-F9001AW01 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT J J J J J AD AD AC AC AC SW705 SW706 SW707 SW708 SW709 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT J J J J J AC AC AC AC AC SW710 SW711 SW712 92LSWICH1401AT J 92LSWICH1401AT J 92LSWICH1401AT J AC AC AC SW713 SW714 92LSWICH1401AT J 92LSWICH1401AT J AC AC SW715 SW716 SW717 SW722 SW723 SW724 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT J J J J J J AC AC AC AC AC AC SW725 SW728 92LSWICH1401AT J 92LSWICH1401AT J AC AC SW729 SW730 SWM3(260-9) 92LSWICH1401AT J 92LSWICH1401AT J 92LM-SW1676A J AC AC AC AV AD AC AD AP DESCRIPTION Plug,3Pin Plug,7Pin Plug,3Pin Socket,24Pin Plug,6Pin Plug,3Pin Plug,8Pin Plug,13Pin Plug,2Pin Plug,12Pin Pin Header,2Pin Connector Ass’y,5/5Pin Connector Ass’y,8/8Pin Connector Ass’y,6/6Pin Socket,3Pin Socket,7Pin Socket,24Pin Socket,13Pin Socket,2Pin Fuse,5A/125V Fuse,5A/125V Fuse,2A/250V Flat Cable,24Pin FL Display Flat Wire,6Pin Flat Cable,2Pin Flat Cable,2Pin Optical Fiber Data Link, GP1F32T Jack,Video/AUX Jack,Headphones Switch,Push Type [Volume Jog] Lug Terminal Motor with Chassis [Spindle] Motor with Gear [Sled] Motor with Worm Pulley [T/T Up/Down Loading] Motor,Air Cooling Fan Motor with Pulley [Tape] Photo Interrupter Lug Pin Relay Relay Remote Sensor,N63H380A Terminal,Speaker Solenoid Ass’y [Tape] Solenoid Ass’y [CD] Switch,Push Type [Open/Close] Switch,Leaf/Skeleton Type [Mecha Up] Switch,Push Type [Disc Number] Switch,Leaf Type [Pickup In] Switch,Key Type [POWER] Switch,Key Type [CLOCK] Switch,Key Type [TIMER/SLEEP] Switch,Key Type [DISC 1] Switch,Key Type [DISC 2] Switch,Key Type [DISC 3] Switch,Key Type [DISC SKIP] Switch,Key Type [OPEN/CLOSE] Switch,Key Type [REW] Switch,Key Type [REC PAUSE] Switch,Key Type [MEMORY/SET] Switch,Key Type [STOP] Switch,Key Type [TUNER (BAND)] Switch,Key Type [VIDEO/AUX] Switch,Key Type [TAPE] Switch,Key Type [CD] Switch,Key Type [FF] Switch,Key Type [TUNING UP] Switch,Key Type [TUNING DOWN] Switch,Key Type [PLAY] Switch,Key Type [X-BASS/DEMO] Switch,Key Type [EQUALIZER] Switch,Key Type [DIMMER] Switch,Leaf Type [Fool Proof] NO. PRICE RANK PARTS CODE SWM4(260-10) QSW-F9003AWZZ SWM5(260-11) 92LM-SW1658A DESCRIPTION J J AG Switch,Leaf Type [F.A.S.] AB Switch,Leaf Type [CAM] CD MECHANISM PARTS ! 301 302 303 304 305 306 306- 1 NGERH0011AWZZ NGERH0012AWZZ MLEVP0010AWZZ NSFTM0002AWFW 92LM-CUSN1524A 92LHPC1MASY ———— J J J J J J AC AC AC AE AC BG — Gear,Middle Gear,Drive Rail,Guide Shaft,Guide Cushion Pickup Unit Ass’y Pickup Unit (Not Replacement Item) Gear,Rack Spring,Rack Screw,ø2.6×6mm Screw,ø2×5mm Screw,ø2×3mm Washer,ø1.5×ø3.8×0.25mm Motor with Chassis [Spindle] Motor with Gear [Sled] Switch,Leaf Type [Pickup In] 306- 2 306- 3 701 702 703 704 M1 M2 SW4 NGERR0043AFZZ MSPRC0961AFZZ XBSSD26P06000 XHBSD20P05000 XBBSD20P03000 LX-WZ1070AFZZ 92LMTR1858CASY 92LMTR1854BASY QSW-F9001AW01 J J J J J J J J J AC AA AA AA AA AA AS AP AD AM CD Player Base BB Front Panel Ass’y — Front Panel (Not Replacement Item) AE Button,Disc No. AE Button,Open/Close/Disc Skip AE Button,Power AE Button,X-BASS/Demo AG Button,FF/REW/Tuning AD Button,Timer/Sleep/Clock AD Button,Dimmer/Equalizer AK Button,Function AC Operation Ring A AF Operation Ring B AD Cap,Operation Center AD Cover,LED AE Panel,Center Cap AH Panel,Decoration AF Decoration,Play Button AE Decoration,Stop Button AH Panel,AMP. AC Panel,Play Decoration AC Panel,Stop Decoration AC Sheet,Reflector AN Cassette,Holder Ass’y,Tape 1 — Cassette Holder,Tape 1 (Not Replacement Item) AH Cassette Cover,Tape 1 AD Panel,Cassette,Tape 1 AN Cassette,Holder Ass’y,Tape 2 — Cassette Holder,Tape 2 (Not Replacement Item) AH Cassette Cover,Tape 2 AD Panel,Cassette,Tape 2 Button,Volume Ass’y — Button,Volume (Not Replacement Item) AA Spring,Ring Refelector B AB Spring,Cassette,Tape 1 AB Spring,Cassette,Tape 2 AB Stabilizer Ass’y — Stabilizer (Not Replacement Item) AF Magnet,Stabilizer AA Support,Stabilizer Magnet AC Lever,Lock AG Chassis,CD Mechanism AB Support,Pitch AE Lever,Shift AB Lever,Change AB Spring,Solenoid AC Belt,Drive AD Gear,Cam AB Gear,Turntable AC Gear,Drive CABINET PARTS 201 202 202- 1 GCAB-1044AWSA 92LCAB3081AS1 ———— J J 202- 2 202- 3 202- 4 202- 5 202- 6 202- 7 202- 8 202-10 202-11 202-12 202-13 202-14 202-15 202-16 202-17 202-18 202-19 202-20 202-21 202-22 203 203- 1 JKNBZ0557AWSA JKNBZ0558AWSA JKNBZ0559AWSA JKNBZ0560AWSA JKNBZ0563AWSA JKNBZ0622AWSA JKNBZ0621AWSA KNOB3051AASY1 HDECQ0412AWSA HDECQ0413AWSA HDECQ0414AWSA HDECQ0415AWSA HDECQ0417AWSA HDECQ0418AWSC HDECQ0419AWSA HDECQ0420AWSA HDECQ0467AWSA HDECQ0457AWSA HDECQ0458AWSA PSHEP0031AWZZ 92LMEC3051CTS1 ———— J J J J J J J J J J J J J J J J J J J J J 203- 2 203- 3 204 204- 1 GCOVA1221AWSB J HDECQ0408AWSA J 92LMEC3051CTS2 J ———— 204- 2 204- 3 205 205- 1 GCOVA1222AWSB J HDECQ0409AWSA J 92LKNOB3081BS1 J ———— 205- 2 205- 3 206 207 208 208- 1 92LCSPR1431C GCOVA1233AWZZ MSPRD0092AWFJ MSPRD0093AWFJ 92LHOLD3022AS1 ———— J J J J J 208- 2 208- 3 209 210 211 212 213 214 215 216 217 218 PMAGF0001AWZZ 92LSUPT1749D MLEVP0067AWZZ LCHSZ0011AWZZ LHLDZ1141AWZZ MLEVP0066AWZZ MLEVP0068AWZZ MSPRC0024AWFW NBLTK0033AWZZ NGERH0064AWZZ NGERH0065AWZZ NGERK0003AWZZ J J J J J J J J J J J J –5– CD-C662 NO. ! ! PRICE RANK PARTS CODE 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 233- 1 NGERK0004AWZZ NGERK0005AWZZ NGERW0006AWZZ NPLYD0002AWZZ LANGF0032AWZZ LCHSZ0010AWZZ LHLDZ1140AWZZ MLEVP0070AWZZ MSPRC0020AWFJ MSPRD0044AWFJ NROLP0009AWZZ NTNT-0018AWSA PCOVZ1013AWZZ PCUSG0022AWZZ 92LCOV3022AS1 ———— J J J J J J J J J J J J J J J AB AB AC AC AC AM AB AB AB AB AB AK AB AB AM — 233- 2 233- 3 233- 4 234 235 236 239 240 240- 1 92LBADGE1671A GCOVA1224AWSA GCOVA1225AWSA GCAB-1052AWSA GCOVA1232AWZZ 92LN-BAND1318A PCUSG0022AWZZ 92LCAB3081BS1 ———— J J J J J J J J AC AE AE AP AC AA AB 240- 2 241 241- 1 PCUSG0022AWZZ J 92LCAB3081CS1 J ———— AB 241- 2 242 243 245 246 247 247 248 249 250 252 253 254 255 256 257 258 259 260 260- 1 260- 2 260- 3 260- 4 260- 5 260- 6 260- 7(MM1) 260- 8(SOLM1) 260- 9(SWM3) 260-10(SWM4) 260-11(SWM5) 262 263 264 266 267 601 603 604 605 606 607 608 610 611 612 613 614 615 616 617 618 PCUSG0022AWZZ LANGK0059AWFW LBSHC0005AWZZ LCHSM0088AWFW NFANP0001AWZZ GITAR0462AWSA GITAR0466AWSA QFSHD0001AWZZ QACCD0022AWZZ PRDAR0095AWFW PRDAR0140AWFW 92LCSPR1431C LHLDZ1226AWZZ LHLDZ1227AWZZ LHLDZ1228AWZZ LHLDZ1229AWZZ LHLDZ1213AWZZ LHLDZ1204AWSA 92LMEC2744AS1 NBLTK0011AWZZ NBLTK0012AWZZ NBLTK0030AWZZ NROLY0002AWZZ RHEDA0001AWZZ 92LMRPH1746A RMOTV0006AWM1 RPLU-0002AWZZ 92LM-SW1676A QSW-F9003AWZZ 92LM-SW1658A MLIFP0006AWZZ LANGK0057AWFW LANGK0058AWFW LHLDF1001AWZZ QCNWN1481AWZZ XJBSF30P10000 XJBSD30P08000 XJBSD30P10000 LX-HZ0082AFZZ LX-JZ0010AFFD XBBSD20P04000 XJBSF30P10000 XESSD30P10000 XJSSF30P10000 XWHJZ62-09510 XEBSD30P10000 LX-JZ0002AWFD LX-EZ0005AWFD XEBSD30P12000 XBPSD26P05JSO LX-TZ0019AFZZ AB AD AD AR AD AN — J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J — AB AM BB AG AA AC AC AC AC AE AD BK AC AB AC AF AG AM AR AH AC AG AB AE AE AE AC AA AA AA AA AA AA AA AA AA AB AA AA AA AA AB AB DESCRIPTION NO. Gear,Bevel Gear,Loading Gear,Worm Wheel Pulley Support,T/T Lock Lever Chassis,Loading Guide Lever,T/T Lock Spring,T/T Lock Lever Spring,Lock Lever Roller Turntable Cover,Wire Cushion,Leg CD Tray Cover Ass’y Cover,CD Tray (Not Replacement Item) Badge,SHARP Cover,CD Tray Panel,Left Cover,CD Tray Panel,Right Top Cabinet Cover,Volume Refector A Nylon Band,80mm Cushion,Leg Side Panel Ass’y,Left Side Panel,Left (Not Replacement Item) Cushion,Leg Side Panel Ass’y,Right Side Panel,Right (Not Replacement Item) Cushion,Leg Bracket,Motor Fan Support Bushing,AC Power Supply Cord Main Chassis Rotary Fan Rear Panel [For U.S.A.] Rear Panel [Except for U.S.A.] Holder,Fuse AC Power Supply Cord Heat Sink,Main Heat Sink,Sub Spring,Ring Holder,Multi Indicator Holder,Volume Holder,Play,Stop Holder,Function Holder,FL Bracket,Stabilizer Tape Mechanism Ass’y Belt,Main Belt,Main Belt,Sub Pinch Roller Ass’y Head,Erase Head,Record/Playback Motor with Pulley [Tape] Solenoid Ass’y [Tape] Switch,Leaf Type [Fool Proof] Switch,Leaf Type [F.A.S.] Switch,Leaf Type [CAM] Damper,Cassette Holder Bracket,Heat Sink,A Bracket,Heat Sink,B Holder,PWB Lug Wire Screw,ø3×10mm Screw,ø3×8mm Screw,ø3×10mm Screw,ø4×8mm Screw,ø3×10mm Screw,ø2×4mm Screw,ø3×10mm Screw,ø3×10mm Screw,ø3×10mm Washer,ø6.2×ø10×0.9mm Screw,ø3×10mm Screw,ø3×10mm Screw,Special Screw,ø3×12mm Screw,ø2.6×5mm Screw,Special –6– 619 621 622 623 624 625 PRICE RANK PARTS CODE XEBSD26P12000 XHBSD30P06000 XJBSF30P06000 XEBSF30P10000 XJSSD30P10000 XJBSD30P16000 DESCRIPTION J J J J J J AA AA AA AA AA AA Screw,ø2.6×12mm Screw,ø3×6mm Screw,ø3×6mm Screw,ø3×10mm Screw,ø3×10mm Screw,ø3×16mm QANTL0007AWZZ TCAUS0042AWZZ TINSE0249AWZZ TINSZ0419AWZZ J J J J TINSZ0420AWZZ TLABZ0558AWZZ TLABZ0559AWZZ TLABZ0560AWZZ RRMCG0177AWSA GFTAB1022AWSA 92L291-0084 J J J J J J J AK AM/FM Loop Antenna Caution,Energy Star AE Operation Manual [For U.S.A.] Operation Manual [Except for U.S.A.] AB Quick Guide [For U.S.A. Only] AB Label,Feature,Tape 1 AB Label,Feature,Tape 2 Label,Feature,Amp. AS Remote Control Battery Lid,Remote Control Speaker Cord Ass'y ACCESSORIES P.W.B. ASSEMBLY (Not Replacement Item) PWB-A1~4 92LPWB3081MANS J PWB-B1,2 92LPWB3081PWRS J PWB-C PWB-D PWB-E PWB-F 92LPWB3022CDUS QPWBF0027AWZZ QPWBF0341AWZZ QPWBF0106AWZZ — J J J J Main/Display/Switch/Digital Output (Combined Ass’y) — Power Supply/Power Amp. (Combined Ass’y) — CD Servo AD CD Motor (PWB Only) AB Sensor (PWB Only) AF Tape Mechanism (PWB Only) J AZ Cabinet Ass’y Front Panel Support,Woofer Net Frame Ass’y Speaker Cord Ass’y with Capacitors Screw,ø3×10mm AB Screw,ø4×16mm AC Screw,ø4×16mm Paper Pipe AE Catching Holder Felt Label,Specification Cushion Woofer Tweeter OTHER SERVICE PART UDSKA0004AFZZ CD Pickup Lens Cleaner CP-C662 SPEAKER BOX PARTS 901 902 903 904 905 92L051-0075 92L312-0077 92L302-0016 92L121-0173 92L122-0047 J J J J J 907 908 909 910 911 912 913 914 SP1,2 SP3,4 92L372-0109 92L372-0064 92L372-0100 92L316-0072 92L319-0027 92L391-0056 92L351-0333 92L394-0053 VSP0020WBA56A VSP0080TBP36A J J J J J J J J J J CD-C662 CD-C662 306-2 A 306 306-1 701 306-3 B 304 701 302 704 C 702 702 301 D 303 703x2 703x2 E M1 F 305 M2 305x2 G SW4 H PWB-D 1 2 3 4 Figure 7 CD MECHANISM EXPLODED VIEW –– 56 7 –– 5 6 CD-C662 CD-C662 240 PWB-A3 A 608x2 623x2 610x2 622x3 240-1 606 257 601x5 247 PWB-A2 B PWB-A4 254 240-2 610x11 258 FL701 256 PWB-A1 202-14 255 202-15 202-13 C 202-11 202-6 Q852 202-7 Q851 608x2 202-5 202-4 202-12 202-21 202-18 D 603x3 202-2 202-10 Q850 202-3 252 202-20 202-17 249 PWB-F 267 202-8 Silicon Grease 262 610x6 243 202-16 IC901 Silicon Grease 202-19 250 625x2 E 606 604x2 202-1 260(260-1, 260-2, 260-3, 260-4, 260-5, 260-6, 260-7, 260-8, 260-9, 260-10, 260-11) 264 621 262 202-22 202 606 205 F 203-1 203-2 235 205-2 205-3 205-1 604x2 239x2 624x3 248x2 PWB-B1 621 621x2 M901 263 607x2 606x3 PWB-B2 606x2 253 206 G 605x4 242 248 x6 246 204-1 606 241 203-3 204-2 203 H 241-1 204 204-3 207 266 236 241-2 608x2 245 Note: Only the unit and consumale parts are supplied as aprts supply for the Tape mechanism. 1 2 3 4 Figure 8 CABINET EXPLODED VIEW (1/2) –– 57 8 –– 5 6 CD-C662 CD-C662 259 611 208 A 208-3 208-2 601x2 208-1 612 234 230 B 226 SW3 229 C 229 227 229 233-3 601x2 233-2 233-1 233 233-4 D 201 614 228 CD MECHANISM 618 E 619 217 613 223 225 229x2 603 215 211 218 209 219 229 618 219 216 615 F 222 221 231 212 213 SW2 225 220 232 617x2 G 229 224 613 210 M3 214 616x4 PWB-C PWB-E H 613 1 229 2 3 4 Figure 9 CABINET EXPLODED VIEW (2/2) –– 58 9 –– SOLM2 5 6 CD-C662 CP-C662 905 A (with Capacitor C1,2) 907x4 913 SP3,4 902 B 901 C 912 910 D 909x4 911x4 904 908x4 SP1,2 E 903 TWEETER SP3(L-CH) SP4(R-CH) F 914 908x4 TWEETER SP3(L-CH) SP4(R-CH) G C1,2 Capacitor 3.3µF,100V, Electrolytic (N.P.) C1,2 Capacitor BK BK RED WOOFER SP1(L-CH) SP2(R-CH) WOOFER SP1(L-CH) SP2(R-CH) RED BK H 1 2 3 4 Figure 10 SPEAKER EXPLODED VIEW 59 –– –– 10 5 6 CD-C662 PACKING OFF THE SET (FOR U.S.A. ONLY) Setting position of switches and knobs Tape Mechanism STOP UNIT SPAKP0032AWZZ Polyethylene bag 92LBAG1460C1 Polyethylene Bag., Accessories FM/AM Loop Antenna Quick Guide Operation Manual Energy Star Caution Speaker Cord SPAKA0214AWZZ Packing Add.,(Left/Right) SPAKZ0507AWZZ Mira Mat Bottom FRONT SIDE OF SPEAKERS REMOTE CONTROL TOP A Feature Label FRONT Front Speaker(L/R) CP-C662 B A 92L411-0111 Polyethylene bag SPAKZ0517AWZZ Bottom Pad TLABR1023AWZZ Bar Code Label 92L414-0031 Sheet,Mira Mat 92L411-0130 Packing Add. (Top/Bottom) CK BA 92L416-0064 Center Pad SPAKC0764AWZZ Packing Case B Not Replacement Item COPYRIGHT © 1999 BY SHARP CORPORATION SHARP CORPORATION Communication Systems Group Quality & Reliability Control Center Higashihiroshima, Hiroshima 739-0192, Japan Printed in Japan ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher. A9904-2627NS•HA•M SC • LAG – 14 60 – CD-C662 PACKING OFF THE SET (FOR U.S.A. ONLY) Setting position of switches and knobs Tape Mechanism STOP UNIT SPAKP0032AWZZ Polyethylene bag 92LBAG1460C1 Polyethylene Bag., Accessories FM/AM Loop Antenna Quick Guide Operation Manual Energy Star Caution Speaker Cord SPAKA0214AWZZ Packing Add.,(Left/Right) SPAKZ0507AWZZ Mira Mat Bottom FRONT SIDE OF SPEAKERS REMOTE CONTROL TOP A Feature Label FRONT Front Speaker(L/R) CP-C662 B A 92L411-0111 Polyethylene bag SPAKZ0517AWZZ Bottom Pad TLABR1023AWZZ Bar Code Label 92L414-0031 Sheet,Mira Mat 92L411-0130 Packing Add. (Top/Bottom) CK BA 92L416-0064 Center Pad SPAKC0764AWZZ Packing Case B Not Replacement Item COPYRIGHT © 1999 BY SHARP CORPORATION SHARP CORPORATION Communication Systems Group Quality & Reliability Control Center Higashihiroshima, Hiroshima 739-0192, Japan Printed in Japan ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher. A9904-2627NS•HA•M SC • LAG – 14 60 –