Download to the User Guide

Transcript
GFlow
System
GreyFlow Above Ground Series
OIM
MANUAL
USER'S
MANUAL
Operation
Maintenance
Introduction●•Installation
Installation •●Maintenance
Grey water reuse system
IAPMO
GFlow (UP-GF-GF)
ONE YEAR
WARRANTY
CONTENTS:
CONTENTS:
INSTALLATION:
CONTENTS
OPERATION:
IMPORTANT
DO’S AND DON’TS:
Selection & operation
INTRODUCTION:
Requirements
Requirements
Page
Page34
Page45
Page
INSTALLATION:
INSTALLATION:
Parts
List:
Parts�������������������������������������
List: GFlow
GFlow System
System
���������������������������������������������������
Important
Do’sand
andDon’ts
Don’ts
Important
Do’s
Page56
Page
OperatingModes
Modes
Operating
Page
Page10
11
Step One:
One: Gflow
Gflowbuffer
tank positioning
Step
tank positioning
����������������������������������
Step Two:
Two:Plumbing
Plumbing
andpower
power
connection
Step
and
connection
���������������������������������
Page1112
Page
Step�������������������������������
Three: Installation
Installing the
irrigation
watering
system
Step
Three:
of irrigation
watering
system
Page13
14- -1415
Page
MAINTENANCE
MAINTENANCE:
Page15
16
Page
TERMS USA
OF WARRANTY:
AWWS
LIMITED CONSUMER WARRANTY
Page
Page17
17- -1820
DISCLAIMER:
DISCLAIMER
Page
Page19
21
(to be purchased separately)
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
2
Page67- -910
Page
Page
Page12
13
INSTALLATION:
INTRODUCTION:
Congratulation! You have taken an important step towards environmentally friendly living
with your purchase of the Universal GFlow Grey Water Diversion and Reuse System.
IMPORTANT DO’S AND DON’TS:
The GFlow System is designed for above ground applications where the Grey Water
supply pipe is higher than the irrigated garden area.
Please Note: The GFlow System is NOT suitable for the Grey Water from the kitchen
sinks.
The advantages of GFlow are as following:
�������������������������������������
1. Economical
���������������������������������������������������
2. Reliable
3. Low maintenance
4. Easy installation and operation
Manual diversion of the����������������������������������
Grey Water to sewer is done through a 3-way manual valve
supplied with the unit. ���������������������������������
The GFlow
must be used with the Grey Flow Irrigation Kit (UP-GF-DL-CK) sold
�������������������������������
separately.
The GFlow System has Watermark and IAPMO UPC certifications, is approved for use in
all states, and is approved for government Grey Water rebates wherever available.
��������������������������������������������
����������������������������������������������
����������������
Grey Water is wastewater generated
from domestic activities such as laundry, shower,
���������������������������������������
and bathing, which can be recycled on-site for uses such as landscape irrigation and
���������������������
DEFINITION:
constructed wetlands. This wastewater contains no fecal matter (human feces). Grey
Water differs from water from toilets which is designated sewage or blackwater to indicate
it contains human waste.
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
3
REQUIREMENTS:
INSTALLATION:
The Grey Water supply point must be higher than the garden area
The drip-line must be installed below mulch or soil (check for Local State, Municipal and
Council laws and regulations in your area)
IMPORTANT DO’S AND DON’TS:
110 volts power supply must be available
The PVC/ABS plumbing connections must be installed by a licensed plumber
Minimum required garden area applies (REF. TABLE 1.0)
�������������������������������������
TABLE
1.0
���������������������������������������������������
Assumed
Quantity of
number of
Grey Water
people in the
reuse in
house
Gallons/day
Minimum
Recommended
garden area
Soil Type
irrigation area
to irrigate in
in Square Feet
Square Feet
Sand
90
����������������������������������
2
3���������������������������������
75
Loam
130
230 & 590
Clay
185
Sand
115
�������������������������������
3
4
100
Loam
180
320 & 790
Clay
230
Sand
160
4
5
125
Loam
225
395 & 1050
Clay
320
Sand
185
��������������������������������������������
5
6
150
Loam
265
460 & 1180
����������������������������������������������
Clay
370
����������������
Sand
220
���������������������������������������
6
7
175
Loam
320
540 & 1380
���������������������
Clay
440
Number of
bedrooms in
the house
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
4
INSTALLATION:
INSTALLAION:
PARTS LIST:
GFlow Complete System is supplied with:
1 GFlow lid cover
1 2" PVC/ABS inlet outlet
manifold AND
with a 3-way
manual diversion valve
IMPORTANT
DO’S
DON’TS:
2 lint filters
2 wall mounting brackets
1 GFlow filter basket
�������������������������������������
1 GFlow
buffer tank fitted with a float controlled submersible pump
���������������������������������������������������
1 Grey water warning sign
Grey Water Warning Sign
to be visible at all time
The following needs to be purchased separately:
����������������������������������
���������������������������������
Grey Flow Irrigation Kit including:
1 Roll of Grey Flow purple drip-line with integration large passage turbulent 2 G/H
�������������������������������
Flow dripper (328 feet)
25 drip-line fittings
1 punch tool
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
5
INSTALLATION:
INSTALLAION:
IMPORTANT DO’S AND DON’TS
The bottom of the GFlow buffer tank
IMPORTANT DO’S
AND
DON’TS:
must always
be higher
than the level
of the lowest irrigation emitter.
�������������������������������������
���������������������������������������������������
����������������������������������
���������������������������������
�������������������������������
The bottom of the GFlow buffer tank
must never be lower than the level of
the lowest irrigation emitter.
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
6
INSTALLATION:
INSTALLAION:
IMPORTANT DO’S AND DON’TS
IMPORTANT DO’S AND DON’TS
To avoid Grey Water overflow to sewer use all 330 feet of
To avoid grey water overflow to sewer use all 100 metres of
Grey
Flow Dripline*
Drip-line* (100
(330 m)
ft) per
GreyFlow
perstation
station
IMPORTANT DO’S AND DON’TS:
DoDo
notnot
runrun
drip-line
more
thanthan
23 feet
dripline
more
7 metres
from
the
start
of
the
feeder
pipe
from
the
start
of
the
feeder
pipe
�������������������������������������
���������������������������������������������������
Use
minimum
1" feeder
Use
minimum
25 mmpipe
feeder pipe
����������������������������������
���������������������������������
�������������������������������
Use
Rotor
valve
a flow
based
indexer
Use GF
3 way
valve
or aorflow
based
indexer
(notpressure
pressurebased)
based)totosplit
splitthe
the
system
into
(not
system
into
more
than
one
station
(this
ensures
that
more than one station (this ensures that thethe
pumpnever
neverruns
runsagainst
against
closeline)
line)
pump
a aclose
��������������������������������������������
����������������������������������������������
����������������
Maximum
run length
23 feet7 metres
Maximum
run length
���������������������������������������
Do
toto
existing
system
or substitute
drip-line
(the
���������������������
Donot
notconnect
connect
existing
system
or substitute
dripline
supplied
pump
and
filters
have
been
sized
to
suit
the
full
(the supplied pump and filters have been sized to suit330
thefeet
supplied
drip-line
flows
and
dripper
sizes)
full 100 metre supplied dripline flows and dripper sizes)
** IfIf non
FlowDripline
Drip-lineisisused
used
the
warrantymay
maybebevoid.
void.
non Grey
GreyFlow
the
warranty
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
“moving water”
7
7
INSTALLATION:
INSTALLATION:
IMPORTANT DO’S AND DON’TS
IMPORTANT DO’S AND DON’TS
Never operate the GFlow system without the
IMPORTANT
AND DON’TS:
filter basketDO’S
and the lint filters
Grey water inlet
Open
Open 3-way
3 way
diversion valve
diversion
�������������������������������������
���������������������������������������������������
Make
the lint
lint filters
all the
downdown
inside
Makesure
sure to
to insert
insert the
filter filters
allway
the way
the
filter
basket
and
secure
their
position
with
the
supplied
inside the filter basket and secure their position with the
����������������������������������
supplied
holding bracket
holding
bracket
���������������������������������
�������������������������������
2 lint filters
��������������������������������������������
Holding bracket
����������������������������������������������
����������������
���������������������������������������
���������������������
����������������������
8
8
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
“moving water”
INSTALLATION:
INSTALLATION:
IMPORTANT DO’S AND DON’TS
IMPORTANT DO’S AND DON’TS
At each DO’S
filter cleaningAND
time makeDON’TS:
sure to check that the bleed
IMPORTANT
At each filter cleaning
time make sure to check that the
holes
clear
debris
and the
tankisisable
able
drain
bleedare
holes
areof
clear
of debris
andbuffer
the tank
toto
drain
out
outinto
intothe
thegarden
gardenwhen
whenthe
thepump
pumpisis not
not operating
operating
�������������������������������������
���������������������������������������������������
Buffer tank
Tank bleed
bleed holes
holes
����������������������������������
���������������������������������
For
from industrial
industrial grade
grade washing
washingmachines
machinesthe
the
For large
large flows
flows from
GFlow
be increased
increasedininsize
sizebybyconnecting
connecting two
GFlow buffer
buffer tank can be
�������������������������������
two
or more
GFlow
tanks
in series
or
more
GFlow
buffer
tanks
in series
1” plug
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
Join
Joinboth
bothbuffer
tanks tanks
with with
1"25oror132mm
1/4" LDPE
LDPE
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
“moving water”
9
9
INSTALLATION:
INSTALLATION:
OPERATING MODES
OPERATING MODES
GFlow
in shutDON’TS:
off mode
IMPORTANT DO’S
AND
The 3-way diversion
The 3 way diversion
valve
valveisis closed
closed and
and
the
theGrey
grey Water
water is
isforced
forcedinto
intothe
the
sewer
overflow
sewer overflow
Grey water inlet
The grey water
overflows to
�������������������������������������
sewer
���������������������������������������������������
GFlow in operation with clean filters
The 3-way diversion
The 3 way diversion
valve
valveisis open
open and
and the
the
����������������������������������
Grey
is forced
forced
grey Water
water is
intothe
thefilter
filterbasket
basket
���������������������������������
into
Grey water inlet
�������������������������������
Grey water pumped to garden
GFlow in operation with blocked filters
The 3-way diversion
The 3isway
diversion
valve
open
and the
valve is open and the
Grey
is forced
forced
grey Water
water is
into
intothe
thefilter
filterbasket
basket
��������������������������������������������
Grey water inlet
����������������������������������������������
����������������
���������������������������������������
���������������������
The grey water
overflows to
sewer
����������������������
10
10
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
“moving water”
INSTALLATION:
INSTALLATION
- STEP ONE:
STEP ONE: GFLOW BUFFER TANK POSITIONING
IMPORTANT DO’S AND DON’TS:
�������������������������������������
���������������������������������������������������
����������������������������������
���������������������������������
�������������������������������
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
buffer tank
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
11
INSTALLATION:
INSTALLATION
- STEP ONE:
STEP TWO: PLUMBING AND POWER
STEP TWO: PLUMBING
AND POWER
CONNECTION
CONNECTION
IMPORTANT
Outdoor GPO DO’S AND DON’TS:
Option 1
�������������������������������������
���������������������������������������������������
Grey water inlet
The grey water
overflows to
����������������������������������
sewer
���������������������������������
Outdoor GPO
�������������������������������
Option 2
Grey water inlet
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
The grey water
overflows to
sewer
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
12
12
“moving water”
INSTALLATION:
INSTALLATION
:
STEP THREE: INSTALLING THE
IRRIGATION SYSTEM
STEP THREE: INSTALLATION
OF
IRRIGATION SYSTEM
IMPORTANTHouse
DO’S AND DON’TS:
exterior wall
Wall mounted option
Minimum
�������������������������������������
Minimumpipe
pipe
size
1"
size
25mm
���������������������������������������������������
Paving
Ground level
Garden
Paving
4"
minimum
mulch
100mm
minimum
mulch
cover
cover
����������������������������������
Sub-mulch layout
���������������������������������
�������������������������������
Make
with
Make aa hole
hole with
punch
tool
&
punch tool &insert
insert
dripline fittings
takeoff
drip-line
Sub-surface layout
Grey Water Warning Sign
to be visible at all times
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
Install
feetbelow
belowground
groundlevel
levelwith
with
Install 330
100mm
dripline outlet
drip-line
outlet facing
facing downloads
downloads
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
“moving water”
13
13
INSTALLATION:
INSTALLATION:
STEP THREE: INSTALLING THE
STEP THREE: INSTALLATION
OF
IRRIGATION SYSTEM
IRRIGATION SYSTEM
IMPORTANT DO’S AND DON’TS:
Sub-soil
layoutsystem
Single zone
dispersal
1/2"
breaker/airbleed
bleed
1/2" vacuum
vacuum breaker/air
@ highest
highest point
at
point(if(ifrequired)
required)
1"
polypoly
25 low
mm density
low density
supply pipe
pipe
�������������������������������������
fittings
takeoffs
���������������������������������������������������
Drip-Line
Purple
2 G/H
Tiran
17 Purple
8 L/hr
@at.312"
m spacing
spacing
����������������������������������
���������������������������������
�������������������������������
1"
25low
mmdensity
low density
poly
flush
poly flush pipe
pipe
Punch a hole in
the poly using
Punch a hole in the
enclosed
1/8"
poly using2enclosed
punch
tool tool
7 mm punch
length 23'-0"
Maximum length
7m
1" barbed
25 mm barbed
��������������������������������������������
manual
flushvalve
valve
25ratchet
mm ratchet
manual flush
1"
clip clip
����������������������������������������������
25 plug
mm end plug
1" end
����������������
���������������������������������������
���������������������
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
14
14
“moving water”
INSTALLATION:
MAINTENANCE:
RECOMMENDED MAINTENANCE
To retain the original reliability and performance of the GFlow System the following
IMPORTANT
DO’S AND DON’TS:
maintenance procedure should be followed. Please ensure that you wash your hands
thoroughly after any contact with Grey Water or handling any part of the GFlow System.
The following maintenance steps should be carried every 3 months and not less
than once every 6 months:
A) Open top cover of the GFlow buffer tank
�������������������������������������
the filter basket with the primary sponge filters and wash thoroughly in a bucket
B) Remove
���������������������������������������������������
with
a garden hose or in any basin not connected to the dedicated Grey Water line.
C) Ensure that the bleed holes located at the base of the 1” riser are clear of debris and
that the buffer tank is able to drain out into the garden when the pump is not operating.
D) Reinsert the filter basket in its original position; close the lid of the buffer tank and the
GFlow system is ready to operate again.
����������������������������������
���������������������������������
The following maintenance
steps should be carried out once a year:
A) Open top cover of the GFlow buffer tank.
�������������������������������
B) Remove the filter basket with the primary sponge filters and wash thoroughly in a bucket
with a garden hose or in any basin not connected to the dedicated Grey Water line.
C) Wash thoroughly the buffer tank with a garden hose and drain the buffer tank using any
of the two cleaning outlets.
D) Disconnect the GFlow pump and connect the supplied going away backup quick
��������������������������������������������
connector
����������������������������������������������
E) Flush the Grey Flow drip-line
with fresh water for about five minutes.
����������������
���������������������������������������
F) Reinsert the Filter basket, reconnect
the pump, close the lid of the GFlow buffer tank
���������������������
and the GFlow system is ready to operate again.
G) Top up mulch over the Grey Flow drip-line to a minimum depth of 4" (the Grey Flow
Drip-line will need to be replaced every 5 to 8 years).
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
15
INSTALLATION:
IMPORTANT DO’S AND DON’TS:
�������������������������������������
���������������������������������������������������
����������������������������������
���������������������������������
�������������������������������
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
16
INSTALLATION:
AWWS USA LIMITED CONSUMER WARRANTY
IMPORTANT DO’S AND DON’TS:
ONE YEAR LIMITED WARRANTY
AWWS USA, LLC ("AWWS") warrants this product against material defects in materials and
workmanship for a period of ONE YEAR from the date of original retail purchase ("warranty
period"). Warranty work will be done in accordance with the following terms and conditions.
This warranty only benefits the original purchaser.
�������������������������������������
THIS WARRANTY
COVERS ONLY DEFECTS IN MATERIAL AND WORKMANSHIP.
���������������������������������������������������
THIS WARRANTY DOES NOT COVER ANY OF THE FOLLOWING:
1. Expendable items that can wear out from normal use, including but not limited to, filters or
similar perishable parts.
����������������������������������
2. Damage to or failure of this System if it is not installed, operated, or maintained according to
���������������������������������
all instructions supplied with the System.
3. Damage
to or failure of this System resulting from accident, abuse, misuse, or use for other
�������������������������������
than its intended purpose, Act of God.
4. Damage to or failure of parts or systems resulting incomplete or improper installation or from
unauthorized modifications made to this System.
5. If you purchased the System from an unauthorized retailer or dealer.
6. Damage caused by power surges, electrical storm damage, incorrect power supply, or insect
��������������������������������������������
or vermin infestation.
����������������������������������������������
7. Damage to or failure of parts if this
System is serviced or repaired by anyone other than an
����������������
���������������������������������������
Authorized Service Center.
���������������������
8. This warranty extends only to you, the original purchaser. It is not transferable to anyone
who subsequently purchased this product from you.
9. Use for more than a single family or use in a commercial establishment or for commercial
non-household purposes.
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
17
INSTALLATION:
10. Parts and Systems not supplied by AWWS USA are not covered by this warranty.
Any item which has been repaired or replaced under this warranty shall be covered for the
remainder of the original warranty as extended by the number of days that the product has been
out of your hands for repair.
IMPORTANT DO’S AND DON’TS:
YOUR RESPONSIBILITY
The above limited warranties are subject to the following conditions:
You must provide your original bill of sale, invoice or other proof of purchase of the System
�������������������������������������
showing that
you are the original purchaser, that the purchase was made within one year of the
���������������������������������������������������
date of your claim and that you purchased it from an authorized dealer or retailer. No warranty
work will be done without this information. Keep a copy of your receipt or invoice for your own
records.
These limited warranties are effective only if this System is purchased and used in the United
����������������������������������
States.
���������������������������������
Labor and service charges for warranty repair, installation, set up, and adjustment of customer
controls are
not covered by these limited warranties.
�������������������������������
Should you encounter a defect in the System, go to WWW.AWWS.US to find the closest
authorized service center. Contact the center and it will arrange for an inspection and corrective
action, if needed and if covered by this warranty.
Should the center determine that the System is not covered by this warranty; any corrective work
will be performed at your request and��������������������������������������������
at your expense. If the center makes a second and/or
����������������������������������������������
subsequent visit and determines that����������������
there is no problem or that the System is not covered, the
service call will be charged to you. ���������������������������������������
���������������������
When making a warranty claim, please be prepared to provide a description of the System,
your name, address, work day telephone number, a description of the problem, the date you
purchased the System and the identify of the seller.
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
18
INSTALLATION:
DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES
1. ALL IMPLIED WARRANTIES, INCLUDING IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN
DURATION TO ONE YEAR FROM THE DATE YOU PURCHASED THE PRODUCT.
IMPORTANT DO’S AND DON’TS:
2. NEITHER AWWS NOR ITS AFFILIATES ARE RESPONSIBLE OR LIABLE FOR ANY
LOSS, INCONVENIENCE OR DAMAGE, WHETHER SPECIAL, EXEMPLARY, DIRECT,
INCIDENTAL, CONSEQUENTIAL OR OTHERWISE, AND WHETHER KNOWN OR
SHOULD HAVE BEEN KNOWN TO AWWS, INCLUDING DAMAGE TO OR REPLACEMENT
OF OTHER EQUIPMENT AND PROPERTY AND PERSONAL INJURY RESULTING
FROM ANY BREACH OF WARRANTY, THE INABILITY TO USE THE PRODUCT OR
UNDER
ANY LEGAL THEORY IN CONTRACT OR TORT. THESE WARRANTIES AND
�������������������������������������
REMEDIES ARE THE SOLE AND EXCLUSIVE WARRANTIES AND REMEDIES GIVEN BY
���������������������������������������������������
AWWS IN CONNECTION WITH THE SALE AND USE OF THE PRODUCT. NO OTHER
WARRANTIES, ORAL OR WRITTEN, EXPRESS OR IMPLIED ARE GIVEN.
3. IN ANY EVENT, AWWS'S ENTIRE LIABILITY SHALL BE LIMITED TO THE ACTUAL
PURCHASE PRICE YOU PAID TO THE RETAIL SELLER OF THE DEFECTIVE PRODUCT.
THIS LIMITATION APPLIES
WHETHER DAMAGES ARE SOUGHT OR A CLAIM MADE,
����������������������������������
UNDER THIS WARRANTY
OR AS A TORT CLAIM (INCLUDING NEGLIGENCE AND
���������������������������������
STRICT PRODUCT LIABILITY), A CONTRACT CLAIM OR ANY OTHER CLAIM. THIS
�������������������������������
LIMITATION
CANNOT BE WAIVED OR AMENDED BY ANY PERSON. THIS LIMITATION
OF LIABILITY IS EFFECTIVE EVEN IF AWWS OR ANY AUTHORIZED REPRESENTATIVE
OF AWWS HAS BEEN ADVISED BY YOU OF THE POSSIBILITY OF SUCH DAMAGES.
THIS LIMITATION OF LIABILITY, HOWEVER, SHALL NOT APPLY TO CLAIMS OF
PERSONAL INJURY.
4. Some states do not allow the exclusion or limitation of implied warranties or liability
for incidental or consequential��������������������������������������������
damages, or do not allow a limitation on how long an
����������������������������������������������
implied warranty lasts, so the above
limitations or exclusions may not apply to you.
����������������
You are advised to contact applicable
state laws for a full determination of your rights.
���������������������������������������
���������������������
This warranty gives you specific
legal rights, and you may have other rights which
vary from state to state.
5. No AWWS dealer, agent or employee is authorized to make any modification, extension,
change or amendment to this warranty.
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������
19
INSTALLATION:
IMPORTANT DO’S AND DON’TS:
�������������������������������������
���������������������������������������������������
����������������������������������
���������������������������������
�������������������������������
Head Office USA
9901 San Fernando Rd. #33
Los Angeles, CA 91331
Phone: (310) 869-7676
www.awws.us
��������������������������������������������
����������������������������������������������
����������������
���������������������������������������
���������������������
IAPMO
����������������������
���������������������������������������������������������
������������������������������������������������������
�������������������������������������������������������