Download Nokia Asha 500 RM-934_972_972 L1L2 Service Manual - Nokia-X
Transcript
Service Manual for L1 and L2 Nokia Asha 500 Dual SIM RM-934, RM-972 Nokia Asha 500 RM-973 Key features z z z z z 2.8" QVGA Display Capacitive touch screen and back key 2 MP Camera Wi-Fi support Micro SD card support up to 32 GB Check the repair policy before performing any mechanical repair on Service Level 1&2! Version 1.0 Exploded view Disassembly steps More Solder components Assembly hints More Service devices More More Product controls and interfaces More Service concept More ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. More Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 1 Exploded view A-COVER ASSEMBLY (I0001 - I0005) TOUCH WINDOW PROTECTIVE TAPE I0005 A-COVER I0001 TOUCH PANEL I0002 EARPIECE GASKET I0004 EARPIECE I0003 DISPLAY I0014 2 LIGHT SWAP PACKAGE DISPLAY CONDUCTIVE ADHESIVE I0012 (I0006 - I0013) LIGHT SWAP PWB I0008 BB SHIELDING LID I0009 TOUCH IC GASKET I0007 RF SHIELDING LID I0010 WLAN SHIELDING LID I0011 CAMERA I0006 3 TYPE LABEL I0013 D-COVER ASSEMBLY IHF SPEAKER I0015 (I0016 - I0020) SPEAKER BOTTOM GASKET I0016 SIM LID I0019 D-COVER I0020 SPEAKER MESH I0017 BT ANTENNA I0018 RELEASE BUTTON I0022 GSM ANTENNA MODULE I0021 SCREW TORX+ SIZE 6 M1.6 x 4.3 I0023 B-COVER I0024 Only available as assembly ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. Not reuseable after removal Repair/swap only in level 3 Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 Disassembly steps 1) For disassembling you need the Nokia Standard toolkit version 2. You will also need the camera removal tool SS-276. 2) Protect the TOUCH PANEL with protective film. 3) Push from the RELEASE BUTTON to release the B-COVER. 4) Remove the B-COVER. 5) Unscrew the four Torx+ size 6 screws in the order shown. 6) Start releasing the D-COVER from the top left corner with the SRT-6 to detach the two shown clips. 7) Then release the other clip on the left side of the device. 8) Then release the two clips on the right side of the device 9) Remove the D-COVER. 10) Open the DISPLAY connector. Be careful not to damage the connector or any components nearby. 11) To remove the ENGINE BOARD, first release the shown clip with the SRT-6. 12) Then release the other shown clip with the SRT-6. 13) Remove the ENGINE BOARD. 14) Protect the DISPLAY with protective film. 15) Release the DISPLAY by carefully sliding the SS-93 under it to detach the adhesive. 16) Remove the DISPLAY. 17) Release one corner of the TOUCH IC GASKET with the dental tool and remove it with tweezers. Be careful not to injure yourself or damage the ENGINE BOARD with the sharp end of the dental tool. Do not use the TOUCH IC GASKET again. Disard it. 18) Peel off the two DISPLAY CONDUCTIVE ADHESIVES with the SS-93. Do not use them again. Discard them. 19) Use the SS-276 to remove the CAMERA. Push the SS-276 to the CAMERA socket and hold down the button on top of the SS-276. 20) Pull up the CAMERA. 21) Use the SS-93 to release the IHF SPEAKER. Remove the IHF SPEAKER with tweezers. 22) Remove and discard the SPEAKER BOTTOM GASKET with the dental tool. 23) Use the SS-93 to release the hook holding the ANTENNA MODULE. 24) Push up to release the ANTENNA MODULE as shown with the SRT-6. Remove the ANTENNA MODULE. 25) Release the RELEASE BUTTON with the SRT-6 and remove it. 26) Release one corner of the SPEAKER MESH with the dental tool and peel it off with tweezrs. Do not use the SPEAKER MESH again. DIscard it. 27) Protect the other side of the TOUCH PANEL with protective film. 28) Release the EARPIECE with the dental tool and remove it with weezers. Do not use the EARPIECE again. Discard it. 29) Remove and discard the EARPIECE GASKET. 30) The Nokia Asha 500 disassembly procedure is complete. -END OF DISASSEMBLY- ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 Assembly hints 1) Fasten the four Torx+ size 6 screws in the order shown to the torque of 20 Ncm. ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 Solder components TOP BOTTOM S1000 Volume + switch Volume switch S1002 J7401 J7402 J7400 Power/Lock switch GSM Ant gnd spring GSM Ant gnd spring GSM Ant spring ©2013 Nokia | Confidential | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 AC-20 Travel charger Service devices BL-4U Battery Nokia Standard Toolkit (v2) For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer contacts for tool re-order can be found in “Recommended service equipment” document on Nokia Online. ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. SS-276 Camera removal tool Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 1 Product controls and interfaces 1 — Micro-USB connector 2 2 — 3.5 mm AHJ connector 3 — Earpiece 3 4 — Touch screen 5 — Back key 6 — Microphone 7 — Camera 8 — Volume/Zoom up 4 9 — Volume/Zoom down 10 — Lock/Power key 11 — Back cover release button 12 — BT/WLAN Antenna area 5 13 — Loudspeaker 6 7 14 — Main antenna area 12 8 9 10 13 11 14 ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 Service concept Flashing concept Service software CA-101 Care Dummy Battery with power supply via Nokia charger or product specific battery Transceiver ©2013 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 500 Dual SIM, Nokia Asha 500 RM-934 RM-972 (Dual SIM), RM-973 (Single SIM) Version 1.0 Version history Version Date Description 1.0 27.11.2013 First published version ©2013 Nokia | Nokia Internal Use only | All Rights Reserved.