Download CFD-G555CP/G555CPK

CFD-G555CP/G555CPK
SERVICE MANUAL
Canadian Model
CFD-G555CPK
E Model
Australian Model
Ver. 1.1 2006.04
CFD-G555CP
Mexican Model
CFD-G555CPK
Photo : CFD-G555CP
CD
Section
TAPE
Section
Model Name Using Similar Mechanism
CFD-G550CP
CD Mechanism Type
KSM-213CDP/C2NP
Optical Pick-up Type
KSS-213C
Model Name Using Similar Mechanism
CFD-G500/G550
Tape Transport Mechanism Type
MF-G500
SPECIFICATIONS
CD player section
System
Compact disc digital audio system
Laser diode properties
Emission duration: Continuous
Laser output: Less than 44.6 µW
(This output is the value measured at a
distance of about 200 mm from the objective
lens surface on the optical pick-up block with
7 mm aperture.)
Number of channels
2
Frequency response
20 - 20 000 Hz +1/–2 dB
Wow and flutter
Below measurable limit
Radio section
Frequency range
FM: 87.5 - 108 MHz
AM:531 - 1 611 kHz (9 kHz step)(G555CP)
530 - 1 610 kHz (10 kHz step)(G555CP)
530 - 1 710 kHz (G555CPK)
Antennas
FM: Telescopic antenna
AM: Built-in ferrite bar antenna
Cassette-corder section
Recording system
4-track 2 channel stereo
Fast winding time
Approx. 120 s (sec.) with Sony cassette C-60
9-887-100-02
2006D16-1
© 2006.04
Frequency response
TYPE I (normal): 70 - 13 000 Hz
General
Speaker
Full range: 10 cm dia., 3.2 Ω, cone type (2)
Woofer: 10 cm dia., 4 Ω, cone type (1)
Outputs
Headphones jack (stereo minijack)
For 16 - 68 Ω impedance headphones
Power output
4 W + 4 W (at 3.2 Ω, 10% harmonic
distortion)
Woofer:
12 W (at 4 Ω, 10% harmonic distortion)
Power requirements
For CD radio cassette-corder:
230 V AC, 50 Hz (G555CP: SP, E41, AUS)
120 V AC, 60 Hz (G555CP: E92/G555CPK)
12 V DC, 8 R20 (size D) batteries
For remote control:
3 V DC, 2 R03 (size AAA) batteries
Power consumption
AC 30 W
Battery life
For CD radio cassette-corder:
FM recording
Sony R20P: approx. 6 h
Sony alkaline LR20: approx. 18 h
Sony Corporation
Personal Audio Division
Published by Sony Techno Create Corporation
Tape playback
Sony R20P: approx. 1.5 h
Sony alkaline LR20: approx. 6 h
CD playback
Sony R20P: approx. 1 h
Sony alkaline LR20: approx. 4 h
Dimensions
Approx. 530 × 241 × 369 mm (w/h/d)
(incl. projecting parts)
Mass
Approx. 8.0 kg (incl. batteries)
Supplied accessories
AC power cord (1)
Remote control (1)
• Abbreviation
AUS : Australian model
E41 : AC 230V area in E model
E92 : AC 120V area in E model
MX : Mexican model
SP
: Singapore model
Design and specifications are subject to change
without notice.
CD RADIO CASSETTE-CORDER
CFD-G555CP/G555CPK
Ver. 1.1
TABLE OF CONTENTS
1.
SERVICING NOTES ............................................... 3
2.
GENERAL ................................................................... 4
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
Disassembly Flow ...........................................................
Cabinet (Upper) (1) Section ............................................
Cabinet (Upper) (2) Section ............................................
Cabinet (Front) Section ...................................................
TUNER KEY Board, VOL KEY Board ..........................
LCD Panel Assy ..............................................................
LED Board ......................................................................
LCD Board ......................................................................
POWER Board, TRANS Board .......................................
CD KEY Board (CFD-G555CPK) ..................................
MIC Board, POWER KEY Board,
H/P Board (CFD-G555CPK) ...........................................
CD KEY Board (CFD-G555CP) .....................................
TUNER Board (CFD-G555CPK) ...................................
H/P Board, TUNER Board (CFD-G555CP) ...................
MAIN Board ....................................................................
CD Block Section ............................................................
Optical Pick-up (KSS-213C) ...........................................
Tape Mechanism Deck ....................................................
TC Board .........................................................................
Main Belt, Sub Belt .........................................................
3-12.
3-13.
3-14.
3-15.
3-16.
3-17.
3-18.
3-19.
3-20.
8
9
9
10
10
11
12
13
14
14
15
15
16
16
17
17
18
18
19
19
4.
MECHANICAL ADJUSTMENTS ......................... 20
5.
ELECTRICAL ADJUSTMENTS .......................... 20
6.
DIAGRAMS
6-1.
6-2.
6-3.
6-4.
6-5.
6-6.
Block Diagram – CD/MP3 Section – .............................
Block Diagram – MAIN Section – .................................
Printed Wiring Board – CD Section – ............................
Schematic Diagram – CD Section – ...............................
Printed Wiring Board – TUNER Section – ....................
Schematic Diagram – TUNER Section – .......................
24
25
26
27
28
29
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of soldering iron around 270˚C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
6-7.
6-8.
6-9.
6-10.
6-11.
6-12.
6-13.
6-14.
6-15.
6-16.
6-17.
6-18.
Printed Wiring Board – TC Section – .............................
Schematic Diagram – TC Section – ...............................
Printed Wiring Boards – MAIN Section (G555CP) – ....
Printed Wiring Boards – MAIN Section (G555CPK) – .
Schematic Diagram – MAIN Section (1/3) – .................
Schematic Diagram – MAIN Section (2/3) – .................
Schematic Diagram
– MAIN (3/3), CONTROL Section – ..............................
Printed Wiring Boards
– CONTROL Section (G555CP) – ..................................
Printed Wiring Boards
– CONTROL Section (G555CPK) – ...............................
Printed Wiring Board – POWER Section (G555CP) – ..
Printed Wiring Board – POWER Section (G555CPK) –
Schematic Diagram – POWER Section – ......................
30
31
32
33
34
35
36
37
38
39
40
41
7.
EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
Overall Section ................................................................
Cabinet (Front) Section ...................................................
Cabinet (Rear) Section ....................................................
Cabinet (Upper) (1) Section (CFD-G555CPK) ...............
Cabinet (Upper) (1) Section (CFD-G555CP) ..................
Cabinet (Upper) (2) Section ............................................
Tape Mechanism Deck Section .......................................
Optical Pick-up Section (KSM-213CDP/C2NP) ............
8.
ELECTRICAL PARTS LIST .................................. 57
49
50
51
52
53
54
55
56
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
2
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COM- POSANTS
QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT
DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
CFD-G555CP/G555CPK
Ver. 1.1
SECTION 1
SERVICING NOTES
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2 V AC range are suitable. (See
Fig. A)
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe more than 30 cm away from the objective lens.
CHUCK PLATE JIG ON REPAIRING
On repairing CD section, playing a disc without the CD lid, use
Chuck Plate Jig.
• Code number of Chuck Plate Jig : X-4918-255-1
To Exposed Metal
Parts on Set
0.15 µF
1.5 k Ω
AC
voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
1. Turn ON the [OPERATE] button and press [CD] button to CD
position.
2. Open the CD lid.
3. Turn on S801 with screwdriver, etc. as following figure.
4. Press the u (CD) button.
5. Confirm the laser diode emission while observing the objecting
lens. When there is no emission, Auto Power Control circuit
or Optical Pick-up is broken.
Objective lens moves up and down three times for focus search.
S801
3
CFD-G555CP/G555CPK
SECTION 2
GENERAL
This section is extracted
from instruction manual.
CFD-G555CP (1/2)
"ASIC/PERATIONS
!UDIO#$
,ISTENINGTOTHERADIO
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
4RACK
NUMBER
0LAYING
TIME
-0DISC
(OLDDOWN45.%ORnȪUNTILTHEFREQUENCY
-0lLE
NUMBER
4O
0AUSEPLAYBACK
6/,ȱāȮàȩANDȺONTHEREMOTEHAVEATACTILE
DOT
"EFOREUSINGTHEUNIT
4OTURNONOFFTHEPOWER
0RESS0/7%2ȷ
4OADJUSTTHEVOLUME
0RESS6/,nȱ
4OLISTENTHROUGHHEADPHONES
#ONNECTTHEHEADPHONESTOTHE­HEADPHONESJACKȸ
4OSELECTTHESOUNDCHARACTERISTIC
0RESS3/5.$ȰREPEATEDLYTOSELECTTHEAUDIO
EMPHASISYOUWANT
#HOOSE
4OGET
0OWERFULCLEANSOUNDSEMPHASIZING
LOWANDHIGHRANGEAUDIO
,IGHTBRIGHTSOUNDSEMPHASIZINGHIGH
ANDMIDDLERANGEAUDIO
0ERCUSSIVESOUNDSEMPHASIZINGBASS
AUDIO
4HEPRESENCEOFVOCALSSTRESSING
MIDDLERANGEAUDIO
4HEWHOLEDYNAMICRANGEFORMUSIC
SUCHASCLASSICALMUSIC
UNIT"!.$ȻONTHEREMOTEREPEATEDLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
h&-v‚h!-v
!FTERTHElLENAMEIS
DISPLAYEDTHEPLAYING
TIMEWILLAPPEAR
DIGITSBEGINTOCHANGEINTHEDISPLAY
4HEUNITAUTOMATICALLYSCANSTHERADIOFREQUENCIES
ANDSTOPSWHENITlNDSACLEARSTATION
)FYOUCANNOTTUNEINASTATIONPRESS45.%ORnȪ
REPEATEDLYTOCHANGETHEFREQUENCYSTEPBYSTEP
7HENAN&-STEREOBROADCASTISRECEIVEDh34v
APPEARS
0RESS
4IP
āONTHEUNITêONTHEREMOTE
Ȯ4ORESUMEPLAYPRESSITAGAIN
)FTHE&-BROADCASTISNOISYPRESS-/$%ȵUNTILh-ONOvAPPEARS
INTHEDISPLAYANDTHERADIOWILLPLAYINMONAURAL
3TOPPLAYBACK
ĄȮ
'OTOTHENEXT
TRACK-0lLE
'OBACKTOTHE
PREVIOUSTRACK
-0lLE
3ELECTAFOLDERON
AN-0DISC
,OCATEAPOINT
WHILELISTENINGTO
THESOUND
Ñȭ
#HANGINGTHE!-TUNINGINTERVAL
%XCEPTFORTHE!USTRALIANMODEL
,OCATEAPOINT
WHILEOBSERVING
THEDISPLAY
,OCATEASPECIlC
TRACK-0lLE
DIRECTLY
2EMOVETHE#$
)FYOUNEEDTOCHANGETHE!-TUNINGINTERVALDOTHE
FOLLOWING
Ãȭ
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
UNITUNTILh!-vISDISPLAYED
&/,$%2TOGOFORWARDAND
&/,$%2nTOGOBACKWARDȬ
ÑFORWARDORÃBACKWARD
ȭWHILEPLAYINGANDHOLDITUNTIL
YOUlNDTHEPOINT
ÑFORWARDORÃBACKWARD
ȭINPAUSEANDHOLDITUNTILYOU
lNDTHEPOINT
4HENUMBERBUTTONȺOFTHETRACK
-0lLEONTHEREMOTE
ì053(/0%.#,/3%ȯ
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
UNITFORSECONDS
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
UNITFORSECONDS
h!-vORh!-vmASHES
0RESS02%3%4ORnȭONTHEUNITTOSELECT
h!-vFORK(ZINTERVALORh!-vFORK(Z
INTERVAL
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
UNIT
!FTERCHANGINGTHETUNINGINTERVALYOUNEEDTORESETYOUR
PRESET!-RADIOSTATIONS
4IPS
s0LAYBACKSTARTSFROMTHETRACK-0lLEYOULASTSTOPPEDPLAYING
2ESUMEPLAY$URINGSTOPTHETRACK-0lLENUMBERTOBEPLAYED
ISDISPLAYED
s4OCANCELTHERESUMEPLAYTOSTARTPLAYFROMTHEBEGINNINGOFTHE
lRSTTRACK-0lLEPRESSĄȮWHILETHE#$ISSTOPPED7HENYOU
OPENTHE#$COMPARTMENTORTURNOFFTHEUNITTHERESUMEPLAYIS
ALSOCANCELED
s7HENYOULOCATEATRACK-0lLENUMBEREDOVERPRESSȺ
ONTHEREMOTElRSTTHENTHECORRESPONDINGNUMBERBUTTONSȺON
THEREMOTE
%XAMPLE4OPLAYTRACK-0lLENUMBERPRESSlRSTTHEN
AND
s4OSELECTATRACK-0lLENUMBEREDORMOREPRESSȺON
THEREMOTETWICETHENTHECORRESPONDINGNUMBERBUTTONSȺONTHE
REMOTE
0LAYINGATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION
0RESSĄìȩONTHEUNITANDINSERTTHETAPEINTO
THETAPECOMPARTMENTWITHTHESIDEYOUWANTTO
PLAYFACINGUPWARD5SE490%)NORMALTAPE
ONLY#LOSETHECOMPARTMENT
-AKESURETHEREISNOSLACKINTHETAPETOAVOID
DAMAGINGTHETAPEORTHEUNIT
.OTE
9OUCANNOTLOCATEASPECIlCTRACK-0lLEIFh3(5&vORh0'-vIS
LITINTHEDISPLAY4URNOFFTHEINDICATIONBYPRESSINGĄȮ
%XAMPLEOFFOLDERSTRUCTUREANDPLAYING
ORDER
4HEPLAYINGORDEROFTHEFOLDERSANDlLESISASFOLLOWS
0RESSàȩONTHEUNIT
&OLDER
-0lLE
4OREINFORCETHEBASSSOUND
0RESS0/7%2$2)6%7//&%27//&%2ON
OR
ON
THEREMOTEȫTOSELECT
ISMOREEFFECTIVE7HENTHE
THEDISPLAY
7//&%2FUNCTIONWORKSTHERINGONTHEFRONTPANEL
LIGHTSUP
4ORETURNTONORMALSOUNDPRESSTHEBUTTONREPEATEDLY
UNTILTHEINDICATIONDISAPPEARSFROMTHEDISPLAY
4HEUNITSTARTSPLAYING
4O
0AUSEPLAYBACK
0RESS
êȩONTHEUNIT4ORESUMEPLAY
PRESSITAGAIN
3TOPPLAYBACK
ĄìȩONTHEUNIT
&ASTFORWARDOR
REWIND
ßORùFASTFORWARDOR
REWINDȩONTHEUNIT
%JECTTHECASSETTE
ĄìȩONTHEUNIT
.OTES
s7HILETHESLEEPINGTIMERISONTHERINGDOESNOTLIGHTEVENIFTHE
7//&%2FUNCTIONISUSED
s7HENYOUUSETHEHEADPHONESTHE7//&%2FUNCTIONDOESNOT
WORK
2ECORDINGONATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION
0RESSĄìȩONTHEUNITTOOPENTHETAPE
COMPARTMENTANDINSERTABLANKTAPEWITHTHESIDE
YOUWANTTORECORDONFACINGUPWARD5SE490%)
NORMALTAPEONLY#LOSETHECOMPARTMENT
0LAYINGA#$-0DISC
3ELECTTHEPROGRAMSOURCEYOUWANTTORECORD
0RESSì053(/0%.#,/3%ȯONTHEUNIT
4ORECORDFROMTHE#$PLAYERPRESSĄȮONTHEUNIT
ANDPLACEA#$
4ORECORDFROMTHERADIOTUNEINTHESTATIONYOUWANT
SEEh,ISTENINGTOTHERADIOv
ANDPLACEADISCWITHTHELABELSIDEUPONTHE#$
COMPARTMENT
4OCLOSETHE#$COMPARTMENTPRESSì053(/0%.
#,/3%ȯONTHEUNIT
.OTESON-0DISCS
0RESSāONTHEUNITàONTHEREMOTEȮ
4HEUNITPLAYSALLTHETRACKS-0lLESONCE
7HENYOUPLACE-0DISCSh-0vAPPEARSINTHE
DISPLAYAFTERTHEUNITREADSTHElLEINFORMATION
4
s7HENTHEDISCISINSERTEDTHEUNITREADSALLTHElLESONTHATDISC
$URINGTHISTIMEh2%!$).'vISDISPLAYED)FTHEREAREMANY
FOLDERSORNON-0lLESONTHEDISCITMAYTAKEALONGTIMEFORPLAY
TOBEGINORFORTHENEXT-0lLETOSTARTPLAY
7ERECOMMENDTHATYOUDONOTSAVEUNNECESSARYFOLDERSORlLES
OTHERTHAN-0ONESINTHEDISCTOBEUSEDFOR-0LISTENING
s,OCATINGASPECIlC-0lLEUSINGTHENUMBERBUTTONSȺONTHE
REMOTEISONLYAVAILABLEFORTHE-0lLESINTHESELECTEDFOLDER
s!FOLDERTHATDOESNOTINCLUDEAN-0lLEISSKIPPED
s-AXIMUMNUMBEROFFOLDERS
-AXIMUMNUMBEROFlLES
-AXIMUMDIRECTORYLEVELS
s&OLDERNAMESANDlLENAMESCANBEDISPLAYEDWITHUPTO
CHARACTERSINCLUDINGQUOTATIONMARKSANDACHARACTEREXTENSION
CODE
s4HECHARACTERS!:AZAND?CANBEDISPLAYEDONTHISUNIT
/THERCHARACTERSAREDISPLAYEDASh
v
s4HISUNITCONFORMSTO6ERSIONOFTHE)$TAGFORMAT)FTHElLE
HASTHE)$TAGINFORMATIONhSONGTITLEvhARTISTNAMEvANDhALBUM
NAMEvCANBEDISPLAYED
s7HENNAMINGBESURETOADDTHElLEEXTENSIONhMPvTOTHElLE
NAME
s)FYOUPUTTHEEXTENSIONhMPvTOAlLEOTHERTHANAN-0lLETHE
UNITCANNOTRECOGNIZETHElLEPROPERLYANDWILLGENERATERANDOM
NOISETHATCOULDDAMAGEYOURSPEAKERS
s4HElLENAMEDOESNOTCORRESPONDTOTHE)$TAG
0RESSĆȩONTHEUNITTOSTARTRECORDINGàIS
DEPRESSEDAUTOMATICALLY
4O
0AUSERECORDING
êȩONTHEUNIT
0RESS
3TOPRECORDING
ĄìȩONTHEUNIT
0RESSTHEBUTTONAGAINTO
RESUMERECORDING
4IPS
s!DJUSTINGTHEVOLUMEORTHEAUDIOEMPHASISWILLNOTAFFECTTHE
RECORDINGLEVEL
s&ORTHEBESTRESULTSUSETHE!#POWERASAPOWERSOURCEFOR
RECORDING
s4OERASEARECORDINGPROCEEDASFOLLOWS
)NSERTTHETAPEWHOSERECORDINGYOUWANTTOERASE
-AKESURETHATh4!0%vISDISPLAYED)Fh4!0%vISNOTDISPLAYED
PRESSàȩONTHEUNITORPRESS&5.#4)/.ȹONTHEREMOTE
UNTILITAPPEARSINTHEDISPLAY
0RESSĆȩONTHEUNIT
CFD-G555CP/G555CPK
CFD-G555CP (2/2)
/THER/PERATIONS
4OCANCEL2EPEAT0LAY
5SINGTHEDISPLAY
0RESS2%0%!4ȲUNTILh2%0vDISAPPEARSFROMTHE
DISPLAY
0RESETTINGRADIOSTATIONS
#HECKINGTHEINFORMATIONOFANAUDIO
#$
0LAYINGTRACKS-0lLESIN
RANDOMORDER3HUFmE0LAY
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
4OCHECKTHETOTALTRACKNUMBERANDPLAYING
TIMEOFTHE#$
9OUCANPLAYTRACKS-0lLESINRANDOMORDER
9OUCANCHECKINFORMATIONABOUTTHE#$USINGTHE
DISPLAY
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
0RESSĄȮ
h#$vAPPEARSINTHEDISPLAY
0RESS-/$%ȵUNTILh3(5&vAPPEARSINTHE
DISPLAY
0RESSāȮONTHEUNITTOSTART3HUFmE0LAY
/NTHEREMOTE
4OTALTRACKNUMBER
4OTALPLAYINGTIME
4OCHECKTHEREMAININGTIME
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
WHILEPLAYINGA#$4HEDISPLAYCHANGESASFOLLOWS
Ô
4HECURRENTTRACKNUMBERANDPLAYINGTIME
€
4HECURRENTTRACKNUMBERANDTHEREMAINING
TIMEOFTHECURRENTTRACK
€
4HENUMBEROFTRACKSLEFTANDTHETIME
REMAININGONTHE#$
#HECKINGTHEINFORMATIONOFAN-0
DISC
4OCHECKTHETOTALFOLDERNUMBERANDTOTAL
lLENUMBERONTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALFOLDER
NUMBER
4OCANCEL3HUFmE0LAY
3TOPPLAYINGlRST4HENPRESS-/$%ȵUNTILh3(5&v
DISAPPEARSFROMTHEDISPLAY
4IPS
s$URING3HUFmE0LAYYOUCANNOTSELECTTHEPREVIOUSTRACK-0lLE
BYPRESSINGÃȭ
s4HERESUMEFUNCTIONDOESNOTWORKDURING3HUFmE0LAY
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
WHILEPLAYINGAN-0DISC4HEDISPLAYCHANGESAS
FOLLOWS
#REATINGYOUROWNPROGRAM
0ROGRAM0LAY
9OUCANARRANGETHEPLAYINGORDEROFUPTOTRACKS
-0lLESONA#$7HENPLAYINGAN-0DISCYOUCAN
ALSOPROGRAMUPTOFOLDERS0ROGRAM&OLDER0LAY
0RESSĄȮ
h#$vAPPEARSINTHEDISPLAY
0RESS-/$%ȵUNTILh0'-vmASHESINTHE
DISPLAY
7HENYOUSELECT0ROGRAM&OLDER0LAY-0DISC
ONLYPRESS-/$%ȵUNTILh0'-vANDh&,$2v
APPEARINTHEDISPLAY
%.4%2s-%-/29ȴONTHEUNITFORTHETRACKS
-0lLESYOUWANTTOPROGRAMINTHEORDERYOU
WANT
5SE&/,$%2ORnȬTOSELECTFOLDERSFOR0ROGRAM
&OLDER0LAY
0LAYINGORDER
€
4HECURRENTlLENUMBERANDTHElLENAME
0LAYINGORDER
0ROGRAMEDlLENAME
0LAYINGORDER
0ROGRAMEDFOLDER
NAME
9OUCANPLAYTRACKS-0lLESREPEATEDLYINNORMAL
3HUFmEOR0ROGRAMPLAYMODES
0ROCEEDASFOLLOWS
4OREPEAT $OTHIS
!SINGLE
0RESS2%0%!4ȲUNTILh2%0vAPPEARS
TRACK-0 0RESSÃORÑȭTOSELECTTHETRACK
lLE
-0lLETHATYOUWANTTOREPEAT
0RESSāȮONTHEUNIT
!LLTRACKS 0RESS2%0%!4ȲUNTILh2%0!,,v
-0lLES
APPEARS
ONTHE#$ 0RESSāȮONTHEUNIT
!SELECTED 0RESS2%0%!4ȲUNTILh2%0vAND
FOLDER
h&,$2vAPPEAR
-0DISC 3ELECTTHEFOLDERBYPRESSING&/,$%2
ONLY
OR&/,$%2nȬ
0RESSāȮONTHEUNIT
4RACKS
3ELECT3HUFmE0LAYSEEh0LAYINGTRACKS
-0lLES
-0lLESINRANDOMORDERv
INRANDOM 0RESS2%0%!4ȲUNTILh3(5&vAND
h2%0vAPPEAR
ORDER
0RESSāȮONTHEUNIT
0ROGRAMED 0ROGRAMTRACKS-0lLESSEEh#REATING
TRACKS
YOUROWNPROGRAMv
-0lLES 0RESS2%0%!4ȲUNTILh2%0vAND
h0'-vAPPEAR
0RESSāȮONTHEUNIT
0ROGRAMED 0ROGRAMFOLDERSSEEh#REATINGYOUROWN
FOLDERS
PROGRAMv
-0DISC 0RESS2%0%!4ȲUNTILh2%0vh0'-v
ANDh&,$2vAPPEAR
ONLY
0RESSāȮONTHEUNIT
)FASTATIONCANNOTBEPRESETAUTOMATICALLY
9OUNEEDTOPRESETASTATIONWITHAWEAKSIGNALMANUALLY
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
UNITTOSELECTTHEBAND
4UNEINASTATIONYOUWANT
(OLDDOWN$)30,!9s%.4%2s-%-/29ȴON
THEUNITFORSECONDSUNTILTHEPRESETNUMBER
mASHESINTHEDISPLAY
0RESS02%3%4ORnȭONTHEUNITUNTILTHE
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
UNIT
4HENEWSTATIONREPLACESTHEOLDONE
/NTHEREMOTE
0RESS"!.$ȻUNTILTHEBANDYOUWANTAPPEARS
INTHEDISPLAY
4UNEINASTATIONYOUWANT
(OLDDOWNTHENUMBERBUTTONSȺTHATYOUWANT
TOPRESETTHENEWSTATIONONFORABOUTSECONDS
4OSELECTTHEPRESETNUMBEROVERPRESSȺ
lRSTTHENTHECORRESPONDINGNUMBERBUTTONSȺ
9OUNEEDTOHOLDDOWNTHELASTNUMBERBUTTONTOENTER
FORABOUTSECONDS
%XAMPLE4OSELECTPRESSANDlRSTTHEN
HOLDDOWNFORABOUTSECONDS
4IP
4HEPRESETRADIOSTATIONSREMAININMEMORYEVENIFYOUUNPLUGTHE
!#POWERCORDORREMOVETHEBATTERIES
0LAYINGPRESETRADIOSTATIONS
UNITTOSELECTTHEBAND
0RESS02%3%4ORnȭONTHEUNITTOTUNEIN
THESTOREDSTATION
-0DISC0ROGRAM&OLDER0LAY
h#$vAPPEARSINTHEDISPLAY
UNIT
4HESTATIONSARESTOREDINMEMORYFROMTHELOWER
FREQUENCIESTOTHEHIGHERONES
-0DISC0ROGRAM0LAY
0LAYINGTRACKS-0lLES
REPEATEDLY2EPEAT0LAY
0RESSĄȮ
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
0ROGRAMEDTRACK
NUMBER
€
4HEFOLDERNUMBERANDTHEFOLDERNAME
)FTHEFOLDERDOESNOTHAVEAFOLDERNAMEh2//4vAPPEARSINSTEAD
OFAFOLDERNAME
)FTHElLEDOESNOTHAVE)$INFORMATIONh./4)4,%vh./
!24)34vORh./!,"5-vAPPEARSINTHEDISPLAY
THEUNITFORSECONDSUNTILh!54/vmASHESINTHE
DISPLAY
!UDIO#$0ROGRAM0LAY
4HECURRENTlLENUMBERANDPLAYINGTIME
€
4HECURRENTlLENUMBERAND)$THESONG
TITLETHEARTISTNAMETHEALBUMNAME
UNITTOSELECTTHEBAND
(OLDDOWN2!$)/"!.$s!54/02%3%4ȳON
PRESETNUMBERYOUWANTFORTHESTATIONmASHESIN
THEDISPLAY
0RESSÃORÑȭTHENPRESS$)30,!9s
4OTALlLENUMBER
4OCHECKlLEINFORMATION
Ô
5SEàȮINSTEADOFāȮ
9OUCANSTORERADIOSTATIONSINTOTHEUNITSMEMORY9OU
CANPRESETUPTORADIOSTATIONSFOR&-ANDFOR
!-INANYORDER
0RESSāȮONTHEUNITTOSTART0ROGRAM0LAY
/NTHEREMOTE
s5SEàȮINSTEADOFāȮ
s!FTERYOUHAVESELECTEDh0'-vPRESSTHENUMBER
BUTTONSȺFORTHETRACKS-0lLESYOUWANTTO
PROGRAMINTHEORDERYOUWANT
4OCANCEL0ROGRAM0LAY
3TOPPLAYINGlRST4HENPRESS-/$%ȵUNTILh0'-v
DISAPPEARSFROMTHEDISPLAY
4OCHECKTHEORDEROFTRACKS-0lLES
BEFOREPLAY
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
%VERYTIMEYOUPRESSTHEBUTTONTHETRACKNUMBER-0
lLENAMEORFOLDERNAMEAPPEARSINTHEPROGRAMEDORDER
4OCHANGETHECURRENTPROGRAM
0RESSĄȮONCEIFTHE#$ISSTOPPEDANDTWICEIFTHE
#$ISPLAYING4HECURRENTPROGRAMWILLBEERASED
4HENCREATEANEWPROGRAMFOLLOWINGTHEPROGRAMING
PROCEDURE
/NTHEREMOTE
0RESS"!.$Ȼ
0RESSTHENUMBERBUTTONSȺTOTUNEINTHE
STOREDSTATION
4OTUNEINAPRESETSTATIONOVERPRESSȺlRST
THENCORRESPONDINGNUMBERBUTTONSȺ
%XAMPLE4OTUNEINAPRESETSTATIONPRESS
ANDlRSTANDTHENPRESS
&ALLINGASLEEPTOMUSIC
0LAYTHEMUSICSOURCEYOUWANT
0RESS3,%%0ȶTODISPLAYh3,%%0v
0RESS3,%%0ȶTOSELECTTHEMINUTESUNTILTHE
UNITGOESOFFAUTOMATICALLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
hv‚hv‚hv‚h/&&v‚hv‚hv
‚hv
)FSECONDSHAVEPASSEDAFTERYOUPRESSED3,%%0ȶ
THEMINUTESINTHEDISPLAYAREENTERED
7HENTHEPRESETTIMEHASPASSEDTHEUNITGOESOFF
AUTOMATICALLY
4OCANCELTHESLEEPFUNCTION
0RESS0/7%2ȷTOTURNOFFTHEPOWER
.OTE
7HENYOUAREPLAYINGATAPEUSINGTHISFUNCTION
)FTHETAPELENGTHOFONESIDEISLONGERTHANTHESETTIMETHEUNITWILL
NOTGOOFFUNTILTHETAPEREACHESTHEEND
4IPS
s9OUCANPLAYTHESAMEPROGRAMAGAINSINCETHEPROGRAMISSAVED
UNTILYOUOPENTHE#$COMPARTMENT
s9OUCANRECORDYOUROWNPROGRAM!FTERYOUHAVECREATEDTHE
PROGRAMINSERTABLANKTAPEANDPRESSĆȩONTHEUNITTOSTART
RECORDING
s4HERESUMEFUNCTIONDOESNOTWORKDURING0ROGRAM0LAY
/NTHEREMOTE
s5SEàȮINSTEADOFāȮ
s!FTERYOUHAVESELECTEDh2%0vPRESSTHENUMBER
BUTTONSȺTOSELECTTHETRACK-0lLE
5
CFD-G555CP/G555CPK
CFD-G555CPK (1/2)
"ASIC/PERATIONS
!UDIO#$
,ISTENINGTOTHERADIO
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
4RACK
NUMBER
0LAYING
TIME
-0DISC
UNIT"!.$ȼONTHEREMOTEREPEATEDLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
h&-v‚h!-v
(OLDDOWN45.%ORnȪUNTILTHEFREQUENCY
-0lLE
NUMBER
!FTERTHElLENAMEIS
DISPLAYEDTHEPLAYING
TIMEWILLAPPEAR
4O
0AUSEPLAYBACK
0RESS
āONTHEUNITêONTHEREMOTE
Ȯ4ORESUMEPLAYPRESSITAGAIN
DIGITSBEGINTOCHANGEINTHEDISPLAY
4HEUNITAUTOMATICALLYSCANSTHERADIOFREQUENCIES
ANDSTOPSWHENITlNDSACLEARSTATION
)FYOUCANNOTTUNEINASTATIONPRESS45.%ORnȪ
REPEATEDLYTOCHANGETHEFREQUENCYSTEPBYSTEP
7HENAN&-STEREOBROADCASTISRECEIVEDh34v
APPEARS
4IP
)FTHE&-BROADCASTISNOISYPRESS-/$%ȶUNTILh-ONOvAPPEARS
INTHEDISPLAYANDTHERADIOWILLPLAYINMONAURAL
3TOPPLAYBACK
ĄȮ
'OTOTHENEXT
TRACK-0lLE
'OBACKTOTHE
PREVIOUSTRACK
-0lLE
3ELECTAFOLDERON
AN-0DISC
,OCATEAPOINT
WHILELISTENINGTO
THESOUND
Ñȭ
0LAYINGATAPE
Ãȭ
5SEBUTTONSONTHEUNITFORTHEOPERATION
&/,$%2TOGOFORWARDAND
&/,$%2nTOGOBACKWARDȬ
ÑFORWARDORÃBACKWARD
ȭWHILEPLAYINGANDHOLDITUNTIL
YOUlNDTHEPOINT
6/,ȱāȮàȩANDȻONTHEREMOTEHAVEATACTILE
DOT
,OCATEAPOINT
WHILEOBSERVING
THEDISPLAY
ÑFORWARDORÃBACKWARD
ȭINPAUSEANDHOLDITUNTILYOU
lNDTHEPOINT
"EFOREUSINGTHEUNIT
,OCATEASPECIlC
TRACK-0lLE
DIRECTLY
2EMOVETHE#$
4HENUMBERBUTTONȻOFTHETRACK
-0lLEONTHEREMOTE
4OTURNONOFFTHEPOWER
0RESS0/7%2ȷ
4OADJUSTTHEVOLUME
0RESS6/,nȱ
4OLISTENTHROUGHHEADPHONES
#ONNECTTHEHEADPHONESTOTHE­HEADPHONESJACKȸ
4OSELECTTHESOUNDCHARACTERISTIC
0RESS3/5.$ȰREPEATEDLYTOSELECTTHEAUDIO
EMPHASISYOUWANT
#HOOSE
4OGET
0OWERFULCLEANSOUNDSEMPHASIZING
LOWANDHIGHRANGEAUDIO
,IGHTBRIGHTSOUNDSEMPHASIZINGHIGH
ANDMIDDLERANGEAUDIO
0ERCUSSIVESOUNDSEMPHASIZINGBASS
AUDIO
4HEPRESENCEOFVOCALSSTRESSING
MIDDLERANGEAUDIO
4HEWHOLEDYNAMICRANGEFORMUSIC
SUCHASCLASSICALMUSIC
0RESSĄìȩONTHEUNITANDINSERTTHETAPEINTO
THETAPECOMPARTMENTWITHTHESIDEYOUWANTTO
PLAYFACINGUPWARD5SE490%)NORMALTAPE
ONLY#LOSETHECOMPARTMENT
-AKESURETHEREISNOSLACKINTHETAPETOAVOID
DAMAGINGTHETAPEORTHEUNIT
ì053(/0%.#,/3%ȯ
0RESSàȩONTHEUNIT
4IPS
s0LAYBACKSTARTSFROMTHETRACK-0lLEYOULASTSTOPPEDPLAYING
2ESUMEPLAY$URINGSTOPTHETRACK-0lLENUMBERTOBEPLAYED
ISDISPLAYED
s4OCANCELTHERESUMEPLAYTOSTARTPLAYFROMTHEBEGINNINGOFTHE
lRSTTRACK-0lLEPRESSĄȮWHILETHE#$ISSTOPPED7HENYOU
OPENTHE#$COMPARTMENTORTURNOFFTHEUNITTHERESUMEPLAYIS
ALSOCANCELED
s7HENYOULOCATEATRACK-0lLENUMBEREDOVERPRESSȻ
ONTHEREMOTElRSTTHENTHECORRESPONDINGNUMBERBUTTONSȻON
THEREMOTE
%XAMPLE4OPLAYTRACK-0lLENUMBERPRESSlRSTTHEN
AND
s4OSELECTATRACK-0lLENUMBEREDORMOREPRESSȻON
THEREMOTETWICETHENTHECORRESPONDINGNUMBERBUTTONSȻONTHE
REMOTE
.OTE
9OUCANNOTLOCATEASPECIlCTRACK-0lLEIFh3(5&vORh0'-vIS
LITINTHEDISPLAY4URNOFFTHEINDICATIONBYPRESSINGĄȮ
%XAMPLEOFFOLDERSTRUCTUREANDPLAYING
ORDER
4HEPLAYINGORDEROFTHEFOLDERSANDlLESISASFOLLOWS
&OLDER
-0lLE
4OREINFORCETHEBASSSOUND
0RESS0/7%2$2)6%7//&%27//&%2ON
OR
ON
THEREMOTEȫTOSELECT
THEDISPLAY
ISMOREEFFECTIVE7HENTHE
7//&%2FUNCTIONWORKSTHERINGONTHEFRONTPANEL
LIGHTSUP
4ORETURNTONORMALSOUNDPRESSTHEBUTTONREPEATEDLY
UNTILTHEINDICATIONDISAPPEARSFROMTHEDISPLAY
4HEUNITSTARTSPLAYING
4O
0AUSEPLAYBACK
0RESS
êȩONTHEUNIT4ORESUMEPLAY
PRESSITAGAIN
3TOPPLAYBACK
ĄìȩONTHEUNIT
&ASTFORWARDOR
REWIND
ßORùFASTFORWARDOR
REWINDȩONTHEUNIT
%JECTTHECASSETTE
ĄìȩONTHEUNIT
2ECORDINGONATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION
0RESSĄìȩONTHEUNITTOOPENTHETAPE
COMPARTMENTANDINSERTABLANKTAPEWITHTHESIDE
YOUWANTTORECORDONFACINGUPWARD5SE490%)
NORMALTAPEONLY#LOSETHECOMPARTMENT
3ELECTTHEPROGRAMSOURCEYOUWANTTORECORD
4ORECORDFROMTHE#$PLAYERPRESSĄȮONTHEUNIT
ANDPLACEA#$
4ORECORDFROMTHERADIOTUNEINTHESTATIONYOUWANT
SEEh,ISTENINGTOTHERADIOv
0RESSĆȩONTHEUNITTOSTARTRECORDINGàIS
DEPRESSEDAUTOMATICALLY
4O
0AUSERECORDING
0RESS
êȩONTHEUNIT
0RESSTHEBUTTONAGAINTO
RESUMERECORDING
3TOPRECORDING
ĄìȩONTHEUNIT
.OTES
s7HILETHESLEEPINGTIMERISONTHERINGDOESNOTLIGHTEVENIFTHE
7//&%2FUNCTIONISUSED
s7HENYOUUSETHEHEADPHONESTHE7//&%2FUNCTIONDOESNOT
WORK
4IPS
s!DJUSTINGTHEVOLUMEORTHEAUDIOEMPHASISWILLNOTAFFECTTHE
RECORDINGLEVEL
s&ORTHEBESTRESULTSUSETHE!#POWERASAPOWERSOURCEFOR
RECORDING
s4OERASEARECORDINGPROCEEDASFOLLOWS
)NSERTTHETAPEWHOSERECORDINGYOUWANTTOERASE
-AKESURETHATh4!0%vISDISPLAYED)Fh4!0%vISNOTDISPLAYED
PRESSàȩONTHEUNITORPRESS&5.#4)/.ȹONTHEREMOTE
UNTILITAPPEARSINTHEDISPLAY
0RESSĆȩONTHEUNIT
0LAYINGA#$-0DISC
0RESSì053(/0%.#,/3%ȯONTHEUNIT
ANDPLACEADISCWITHTHELABELSIDEUPONTHE#$
COMPARTMENT
4OCLOSETHE#$COMPARTMENTPRESSì053(/0%.
#,/3%ȯONTHEUNIT
.OTESON-0DISCS
0RESSāONTHEUNITàONTHEREMOTEȮ
4HEUNITPLAYSALLTHETRACKS-0lLESONCE
7HENYOUPLACE-0DISCSh-0vAPPEARSINTHE
DISPLAYAFTERTHEUNITREADSTHElLEINFORMATION
6
s7HENTHEDISCISINSERTEDTHEUNITREADSALLTHElLESONTHATDISC
$URINGTHISTIMEh2%!$).'vISDISPLAYED)FTHEREAREMANY
FOLDERSORNON-0lLESONTHEDISCITMAYTAKEALONGTIMEFORPLAY
TOBEGINORFORTHENEXT-0lLETOSTARTPLAY
7ERECOMMENDTHATYOUDONOTSAVEUNNECESSARYFOLDERSORlLES
OTHERTHAN-0ONESINTHEDISCTOBEUSEDFOR-0LISTENING
s,OCATINGASPECIlC-0lLEUSINGTHENUMBERBUTTONSȻONTHE
REMOTEISONLYAVAILABLEFORTHE-0lLESINTHESELECTEDFOLDER
s!FOLDERTHATDOESNOTINCLUDEAN-0lLEISSKIPPED
s-AXIMUMNUMBEROFFOLDERS
-AXIMUMNUMBEROFlLES
-AXIMUMDIRECTORYLEVELS
s&OLDERNAMESANDlLENAMESCANBEDISPLAYEDWITHUPTO
CHARACTERSINCLUDINGQUOTATIONMARKSANDACHARACTEREXTENSION
CODE
s4HECHARACTERS!:AZAND?CANBEDISPLAYEDONTHISUNIT
/THERCHARACTERSAREDISPLAYEDASh
v
s4HISUNITCONFORMSTO6ERSIONOFTHE)$TAGFORMAT)FTHElLE
HASTHE)$TAGINFORMATIONhSONGTITLEvhARTISTNAMEvANDhALBUM
NAMEvCANBEDISPLAYED
s7HENNAMINGBESURETOADDTHElLEEXTENSIONhMPvTOTHElLE
NAME
s)FYOUPUTTHEEXTENSIONhMPvTOAlLEOTHERTHANAN-0lLETHE
UNITCANNOTRECOGNIZETHElLEPROPERLYANDWILLGENERATERANDOM
NOISETHATCOULDDAMAGEYOURSPEAKERS
s4HElLENAMEDOESNOTCORRESPONDTOTHE)$TAG
CFD-G555CP/G555CPK
CFD-G555CPK (2/2)
/THER/PERATIONS
4OCANCEL2EPEAT0LAY
0RESS2%0%!4ȲUNTILh2%0vDISAPPEARSFROMTHE
DISPLAY
0RESETTINGRADIOSTATIONS
5SINGTHE+ARAOKEFUNCTION
+!2!/+%0/.
#HECKINGTHEINFORMATIONOFANAUDIO
#$
0LAYINGTRACKS-0lLESIN
RANDOMORDER3HUFmE0LAY
9OUCANSTORERADIOSTATIONSINTOTHEUNITSMEMORY9OU
CANPRESETUPTORADIOSTATIONSFOR&-ANDFOR
!-INANYORDER
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
4OCHECKTHETOTALTRACKNUMBERANDPLAYING
TIMEOFTHE#$
9OUCANPLAYTRACKS-0lLESINRANDOMORDER
5SINGTHEDISPLAY
9OUCANCHECKINFORMATIONABOUTTHE#$USINGTHE
DISPLAY
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
0RESSĄȮ
h#$vAPPEARSINTHEDISPLAY
0RESS-/$%ȶUNTILh3(5&vAPPEARSINTHE
DISPLAY
0RESSāȮONTHEUNITTOSTART3HUFmE0LAY
/NTHEREMOTE
4OTALTRACKNUMBER
4OTALPLAYINGTIME
4OCHECKTHEREMAININGTIME
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
WHILEPLAYINGA#$4HEDISPLAYCHANGESASFOLLOWS
Ô
4HECURRENTTRACKNUMBERANDPLAYINGTIME
€
4HECURRENTTRACKNUMBERANDTHEREMAINING
TIMEOFTHECURRENTTRACK
€
4HENUMBEROFTRACKSLEFTANDTHETIME
REMAININGONTHE#$
#HECKINGTHEINFORMATIONOFAN-0
DISC
4OCHECKTHETOTALFOLDERNUMBERANDTOTAL
lLENUMBERONTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALFOLDER
NUMBER
4OCANCEL3HUFmE0LAY
3TOPPLAYINGlRST4HENPRESS-/$%ȶUNTILh3(5&v
DISAPPEARSFROMTHEDISPLAY
4IPS
s$URING3HUFmE0LAYYOUCANNOTSELECTTHEPREVIOUSTRACK-0lLE
BYPRESSINGÃȭ
s4HERESUMEFUNCTIONDOESNOTWORKDURING3HUFmE0LAY
4OTALlLENUMBER
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
WHILEPLAYINGAN-0DISC4HEDISPLAYCHANGESAS
FOLLOWS
#REATINGYOUROWNPROGRAM
0ROGRAM0LAY
9OUCANARRANGETHEPLAYINGORDEROFUPTOTRACKS
-0lLESONA#$7HENPLAYINGAN-0DISCYOUCAN
ALSOPROGRAMUPTOFOLDERS0ROGRAM&OLDER0LAY
0RESSĄȮ
h#$vAPPEARSINTHEDISPLAY
0RESS-/$%ȶUNTILh0'-vmASHESINTHE
DISPLAY
7HENYOUSELECT0ROGRAM&OLDER0LAY-0DISC
ONLYPRESS-/$%ȶUNTILh0'-vANDh&,$2v
APPEARINTHEDISPLAY
%.4%2s-%-/29ȴONTHEUNITFORTHETRACKS
-0lLESYOUWANTTOPROGRAMINTHEORDERYOU
WANT
5SE&/,$%2ORnȬTOSELECTFOLDERSFOR0ROGRAM
&OLDER0LAY
0LAYINGORDER
€
4HECURRENTlLENUMBERANDTHElLENAME
0LAYINGORDER
0ROGRAMEDlLENAME
0LAYINGORDER
0ROGRAMEDFOLDER
NAME
9OUCANPLAYTRACKS-0lLESREPEATEDLYINNORMAL
3HUFmEOR0ROGRAMPLAYMODES
0ROCEEDASFOLLOWS
4OREPEAT $OTHIS
!SINGLE
0RESS2%0%!4ȲUNTILh2%0v
TRACK-0
APPEARS
lLE
0RESSÃORÑȭTOSELECTTHETRACK
-0lLETHATYOUWANTTOREPEAT
0RESSāȮONTHEUNIT
!LLTRACKS 0RESS2%0%!4ȲUNTILh2%0!,,v
-0lLES
APPEARS
ONTHE#$ 0RESSāȮONTHEUNIT
!SELECTED 0RESS2%0%!4ȲUNTILh2%0vAND
FOLDER
h&,$2vAPPEAR
-0DISC 3ELECTTHEFOLDERBYPRESSING&/,$%2
ONLY
OR&/,$%2nȬ
0RESSāȮONTHEUNIT
4RACKS
3ELECT3HUFmE0LAYSEEh0LAYINGTRACKS
-0lLES
-0lLESINRANDOMORDERv
INRANDOM 0RESS2%0%!4ȲUNTILh3(5&vAND
h2%0vAPPEAR
ORDER
0RESSāȮONTHEUNIT
0ROGRAMED 0ROGRAMTRACKS-0lLESSEEh#REATING
TRACKS-0
YOUROWNPROGRAMv
lLES
0RESS2%0%!4ȲUNTILh2%0vAND
h0'-vAPPEAR
0RESSāȮONTHEUNIT
0ROGRAMED 0ROGRAMFOLDERSSEEh#REATINGYOUROWN
FOLDERS
PROGRAMv
-0DISC 0RESS2%0%!4ȲUNTILh2%0vh0'-v
ANDh&,$2vAPPEAR
ONLY
0RESSāȮONTHEUNIT
9OUNEEDTOPRESETASTATIONWITHAWEAKSIGNALMANUALLY
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
UNITTOSELECTTHEBAND
4UNEINASTATIONYOUWANT
(OLDDOWN$)30,!9s%.4%2s-%-/29ȴON
THEUNITFORSECONDSUNTILTHEPRESETNUMBER
mASHESINTHEDISPLAY
0RESS02%3%4ORnȭONTHEUNITUNTILTHE
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
UNIT
4HENEWSTATIONREPLACESTHEOLDONE
/NTHEREMOTE
0RESS"!.$ȼUNTILTHEBANDYOUWANTAPPEARS
INTHEDISPLAY
4HEINDICATORBESIDETHE+!2!/+%0/.BUTTONȵ
LIGHTSUP
0LAYTHESOUNDSOURCE
4URN-)#,%6%,ȵONTHEUNITTOADJUSTTHE
MICROPHONEVOLUME
4OCANCELTHE+ARAOKEFUNCTION
0RESS+!2!/+%0/.ȵORPRESS0/7%2ȷTOTURN
OFFTHEUNIT
.OTES
s-ICROPHONESWITHABUILTINECHOFUNCTIONCANCAUSEAHOWLING
SOUND+EEPTHEVOLUMEOFTHEMICROPHONELOWWITHTHE-)#
,%6%,CONTROLȵ
s7HENTHEHOWLINGOCCURSTURNTHEHEADOFTHEMICROPHONEAWAY
FROMTHESPEAKERS
s7HENRECORDINGFROM#$SORRADIOPROGRAMSWITHTHE+ARAOKE
FUNCTIONISONONLYTHEORIGINALSOUNDWITHTHEVOCALCOMPONENT
WILLBERECORDEDONTHETAPE
s)NPUTFROMAMICROPHONECONNECTEDTOTHE-)#-)8̠JACKCANNOT
BERECORDED
s%VENWHENTHE+ARAOKEFUNCTIONISONTHEVOCALCOMPONENTMAY
NOTBEREDUCEDORADEQUATELYREDUCEDFORSOMESOUNDSOURCES
4UNEINASTATIONYOUWANT
(OLDDOWNTHENUMBERBUTTONSȻTHATYOUWANT
TOPRESETTHENEWSTATIONONFORABOUTSECONDS
4OSELECTTHEPRESETNUMBEROVERPRESSȻ
lRSTTHENTHECORRESPONDINGNUMBERBUTTONSȻ
9OUNEEDTOHOLDDOWNTHELASTNUMBERBUTTONTOENTER
FORABOUTSECONDS
%XAMPLE4OSELECTPRESSANDlRSTTHEN
HOLDDOWNFORABOUTSECONDS
4IP
4HEPRESETRADIOSTATIONSREMAININMEMORYEVENIFYOUUNPLUGTHE
!#POWERCORDORREMOVETHEBATTERIES
0LAYINGPRESETRADIOSTATIONS
UNITTOSELECTTHEBAND
0RESS02%3%4ORnȭONTHEUNITTOTUNEIN
THESTOREDSTATION
-0DISC0ROGRAM&OLDER0LAY
h#$vAPPEARSINTHEDISPLAY
)FASTATIONCANNOTBEPRESETAUTOMATICALLY
0RESS0/7%2ȷTOTURNONTHEUNIT
0RESS+!2!/+%0/.ȵONTHEUNIT
-0DISC0ROGRAM0LAY
0LAYINGTRACKS-0lLES
REPEATEDLY2EPEAT0LAY
0RESSĄȮ
UNIT
4HESTATIONSARESTOREDINMEMORYFROMTHELOWER
FREQUENCIESTOTHEHIGHERONES
-)8ȵJACKONTHEUNIT
)FTHEMICROPHONEHASAPOWERSWITCHSETTHESWITCH
TO/.
0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
0ROGRAMEDTRACK
NUMBER
€
4HEFOLDERNUMBERANDTHEFOLDERNAME
)FTHEFOLDERDOESNOTHAVEAFOLDERNAMEh2//4vAPPEARSINSTEAD
OFAFOLDERNAME
)FTHElLEDOESNOTHAVE)$INFORMATIONh./4)4,%vh./
!24)34vORh./!,"5-vAPPEARSINTHEDISPLAY
0RESS$)30,!9s%.4%2s-%-/29ȴONTHE
#ONNECTAMICROPHONENOTSUPPLIEDTOTHE-)#
!UDIO#$0ROGRAM0LAY
4HECURRENTlLENUMBERANDPLAYINGTIME
€
4HECURRENTlLENUMBERAND)$THESONG
TITLETHEARTISTNAMETHEALBUMNAME
THEUNITFORSECONDSUNTILh!54/vmASHESINTHE
DISPLAY
PRESETNUMBERYOUWANTFORTHESTATIONmASHESIN
THEDISPLAY
0RESSÃORÑȭTHENPRESS$)30,!9s
4OCHECKlLEINFORMATION
Ô
5SEàȮINSTEADOFāȮ
UNITTOSELECTTHEBAND
(OLDDOWN2!$)/"!.$s!54/02%3%4ȳON
4HISFUNCTIONREDUCESTHEVOCALCOMPONENTOFTHESOUND
SOURCESOTHATYOUCANENJOY+ARAOKEWITHYOUR#$S
4APESORRADIOPROGRAMS
5SEBUTTONSONTHEUNITFORTHEOPERATION
/NTHEREMOTE
0RESS"!.$ȼ
0RESSTHENUMBERBUTTONSȻTOTUNEINTHE
STOREDSTATION
4OTUNEINAPRESETSTATIONOVERPRESSȻlRST
THENCORRESPONDINGNUMBERBUTTONSȻ
%XAMPLE4OTUNEINAPRESETSTATIONPRESS
ANDlRSTANDTHENPRESS
&ALLINGASLEEPTOMUSIC
5SEBUTTONSONTHEREMOTEFORTHEOPERATION
0RESSāȮONTHEUNITTOSTART0ROGRAM0LAY
/NTHEREMOTE
s5SEàȮINSTEADOFāȮ
s!FTERYOUHAVESELECTEDh0'-vPRESSTHENUMBER
BUTTONSȻFORTHETRACKS-0lLESYOUWANTTO
PROGRAMINTHEORDERYOUWANT
4OCANCEL0ROGRAM0LAY
3TOPPLAYINGlRST4HENPRESS-/$%ȶUNTILh0'-v
DISAPPEARSFROMTHEDISPLAY
4OCHECKTHEORDEROFTRACKS-0lLES
BEFOREPLAY
0RESS$)30,!9s%.4%2s-%-/29ȴONTHEUNIT
%VERYTIMEYOUPRESSTHEBUTTONTHETRACKNUMBER-0
lLENAMEORFOLDERNAMEAPPEARSINTHEPROGRAMEDORDER
0LAYTHEMUSICSOURCEYOUWANT
0RESS3,%%0ȹONTHEREMOTETODISPLAY
h3,%%0v
0RESS3,%%0ȹONTHEREMOTETOSELECTTHE
MINUTESUNTILTHEUNITGOESOFFAUTOMATICALLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
hv‚hv‚hv‚h/&&v‚hv‚hv
‚hv
)FSECONDSHAVEPASSEDAFTERYOUPRESSED3,%%0ȹ
THEMINUTESINTHEDISPLAYAREENTERED
7HENTHEPRESETTIMEHASPASSEDTHEUNITGOESOFF
AUTOMATICALLY
4OCANCELTHESLEEPFUNCTION
0RESS0/7%2ȷTOTURNOFFTHEPOWER
4OCHANGETHECURRENTPROGRAM
.OTE
0RESSĄȮONCEIFTHE#$ISSTOPPEDANDTWICEIFTHE
#$ISPLAYING4HECURRENTPROGRAMWILLBEERASED
4HENCREATEANEWPROGRAMFOLLOWINGTHEPROGRAMING
PROCEDURE
7HENYOUAREPLAYINGATAPEUSINGTHISFUNCTION
)FTHETAPELENGTHOFONESIDEISLONGERTHANTHESETTIMETHEUNITWILL
NOTGOOFFUNTILTHETAPEREACHESTHEEND
4IPS
s9OUCANPLAYTHESAMEPROGRAMAGAINSINCETHEPROGRAMISSAVED
UNTILYOUOPENTHE#$COMPARTMENT
s9OUCANRECORDYOUROWNPROGRAM!FTERYOUHAVECREATEDTHE
PROGRAMINSERTABLANKTAPEANDPRESSĆȩONTHEUNITTOSTART
RECORDING
s4HERESUMEFUNCTIONDOESNOTWORKDURING0ROGRAM0LAY
/NTHEREMOTE
s5SEàȮINSTEADOFāȮ
s!FTERYOUHAVESELECTEDh2%0vPRESSTHENUMBER
BUTTONSȻTOSELECTTHETRACK-0lLE
7
CFD-G555CP/G555CPK
SECTION 3
DISASSEMBLY
3-1. DISASSEMBLY FLOW
• This set can be disassembled in the order shown below.
SET
3-2. CABINET (UPPER) (1) SECTION
(Page 9)
3-3. CABINET (UPPER) (2) SECTION
(Page 9)
3-4. CABINET (FRONT) SECTION
(Page 10)
CFD-G555CPK model
3-10. CD KEY BOARD
(Page 14)
CFD-G555CP model
3-12. CD KEY BOARD
(Page 15)
3-11. MIC BOARD,
POWER KEY BOARD,
H/P BOARD
(Page 15)
3-5. TUNER KEY BOARD,
VOL KEY BOARD
(Page 10)
3-6. LCD PANEL ASSY
(Page 11)
3-9. POWER BOARD,
TRANS BOARD
(Page 14)
3-7. LED BOARD
(Page 12)
3-8. LCD BOARD
(Page 13)
CFD-G555CPK model
3-13. TUNER BOARD
(Page 16)
CFD-G555CP model
3-14. H/P BOARD,
TUNER BOARD
(Page 16)
3-15. MAIN BOARD
(Page 17)
3-18. TAPE MECHANISM DECK
(Page 18)
3-19. TC BOARD
(Page 19)
8
3-16. CD BLOCK SECTION
(Page 17)
3-20. MAIN BELT,
SUB BELT
(Page 19)
3-17. OPTICAL PICK-UP (KSS-213C)
(Page 18)
CFD-G555CP/G555CPK
Note: Follow the disassembly procedure in the numerical order given.
3-2. CABINET (UPPER) (1) SECTION
1 Open the handle in the
direction of the arrow.
4 two screws
(+BV tapping (B3))
6 two screws
(+BV tapping (B3))
2 seven screws
(+BV tapping (B3))
3 Open the cassette lid.
5 Open the CD lid.
3-3. CABINET (UPPER) (2) SECTION
9 CNP301 (5P)
qa handle
8 CNP392 (4P)
5 CNP804 (2P)
7 CNP393 (4P)
6 flexible flat cable
(11 core) (CNP801)
1 Close the cassette lid.
3
0 cabinet (upper) section
4
2 Close the CD lid.
two claws
9
CFD-G555CP/G555CPK
3-4. CABINET (FRONT) SECTION
4 four screws
(+BV tapping (B3))
5
3 four screws
(+BV tapping (B3))
6 cabinet (front) section
2 four screws
(+BV tapping (B3))
1 battery lid
3-5. TUNER KEY BOARD, VOL KEY BOARD
2 button (function)
6 three screws
(+BV tapping (B2.6))
1 two screws
(+BV tapping (B2.6))
7 button (volume)
9 VOL KEY board
8 three screws
(+P tapping (B2.6))
5 TUNER KEY board
4 three screws
(+P tapping (B2.6))
3 three screws
(+P tapping (B2.6))
10
CFD-G555CP/G555CPK
3-6. LCD PANEL ASSY
5 LCD panel assy
4 five screws
(+BV tapping (B3))
3 woofer speaker
1 two screws
(+BV tapping (B3))
2 two screws
(+BV tapping (B3))
11
CFD-G555CP/G555CPK
3-7. LED BOARD
3
2 two claws
1 two claws
light guide LED plate
6 LED 2 board
7 LED 3 board
claw
claw
4
8 LED 4 board
claw
claw
5 LED 1 board
Route the harnesses as shown below.
harnesses
harnesses
12
CFD-G555CP/G555CPK
3-8. LCD BOARD
3 two screws
(+BV tapping (B3))
1 two screws
(+BV tapping (B3))
4 two LED holders (L)
6 woofer cover
5 alignment ring
2 two LED holders (R)
7 three screws
(+BV tapping (B3))
8 screw
(+BV tapping (B3))
9 rear cover
qa two screws
(+BV tapping (B2.6))
Pass the harnesses through
the notch.
notch
harnesses
0
qs LCD board
harnesses
Remove the harnesses.
13
CFD-G555CP/G555CPK
3-9. POWER BOARD, TRANS BOARD
qa two screws
(+BV tapping (B3))
0 two screws
(+BV tapping (B3))
Remove the harnesses.
7 two screws
(+BV tapping (B3))
9 screw
(+BV tapping (B3))
2 CNP902 (4P)
qs POWER board,
TRANS board
8
5 four screws
(+BV tapping (B3))
6 screw
(+BV tapping (B3))
Remove the harnesses.
1 sheet trans chassis
3-10. CD KEY BOARD (CFD-G555CPK)
2 six screws
(+BV tapping (B2.6))
3 two screws
(+PWH tapping (B2.6))
6 screw
(+BV tapping (B2.6))
5 CD KEY board
7 button (woofer) assy
8 button (CD)
4 KH405 (3P)
14
1 CNP804 (4P)
4 BATTERY1 board
3 screw
(+PWH tapping (B3))
CFD-G555CP/G555CPK
3-11. MIC BOARD, POWER KEY BOARD, H/P BOARD (CFD-G555CPK)
1 screw
(+PWH tapping (B2.6))
4 screw
(+PWH tapping (B2.6))
2 JACK HOLD board
5 MIC board
6 four screws
(+BV tapping (B2.6))
7 POWER KEY board
qa button (power)
8 screw
(+PWH tapping (B2.6))
0 H/P board
3 CNP394 (3P)
9 CNP391 (9P)
3-12. CD KEY BOARD (CFD-G555CP)
2 ten screws
(+BV tapping (B2.6))
3 two screws
(+PWH tapping (B2.6))
5 screw
(+BV tapping (B2.6))
4 CD KEY board
1 CNP804 (3P)
6 button (woofer) assy
7 button (CD)
8 button (power)
15
CFD-G555CP/G555CPK
3-13. TUNER BOARD (CFD-G555CPK)
1 two screws
(+BV tapping (B3))
3 Remove the soldering.
4 TUNER board
2 flexible flat cable
(11core) (CNP1)
3-14. H/P BOARD, TUNER BOARD (CFD-G555CP)
3 Remove the soldering.
1 two screws
(+BV tapping (B3))
5 screw
(+PWH tapping (B2.6))
6 JACK HOLD board
4 TUNER board
7 H/P board
2 flexible flat cable
(11core) (CNP1)
8 CNP391 (9P)
16
CFD-G555CP/G555CPK
3-15. MAIN BOARD
9 flexible flat cable (11 core)
5 three screws
(+BV tapping (B3))
6
8 Remove the soldering.
qs MAIN board
0 Remove the soldering.
4 connector (2P)
7 flexible flat cable
(20 core) (CNJ802)
qa flexible flat cable (11 core)
1 flexible flat cable
(11 core) (CNJ303)
3 CNP806 (4P)
2 CNP303 (6P)
3-16. CD BLOCK SECTION
1 two screws
(+PWH tapping (B2.6))
2 two screws
(+PWH tapping (B2.6))
3 CD block section
17
CFD-G555CP/G555CPK
3-17. OPTICAL PICK-UP (KSS-213C)
5 optical pick-up
1 gear (A)
claw
3
2 claw
4 sled shaft
3-18. TAPE MECHANISM DECK
1 three screws
(+BV tapping (B3))
3 tape mechanism deck
2 Open the cassette lid.
18
CFD-G555CP/G555CPK
3-19. TC BOARD
1 screw
4 TC board
3 Remove soldering from the four points.
yellow red white
black
TC board
2 hook
3-20. MAIN BELT, SUB BELT
3 motor assy
(M971)
1 two screws
(+BIND DT M2 × 6)
2 hook
4 main belt (B1)
5 sub belt (B1)
19
CFD-G555CP/G555CPK
SECTION 4
MECHANICAL ADJUSTMENTS
PRECAUTION
1. Clean the following parts with a denatured-alcohol-moistened
swab :
record/playback head
pinch roller
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head
demagnetizer. (Do not bring the head magnetizer close to the
erase head.)
3. Do not use a magnetized screwdriver for the adjustments.
4. The adjustments should be performed with the rated power
supply voltage (9V) unless otherwise noted.
Torque Measurement
Mode
FWD
Torque meter
CQ-102C
FWD
Back Tension
CQ-102C
FF
CQ-201B
REW
CQ-201B
Meter reading
2.95 – 6.86 mN • m
(30 – 70 g • cm)
(0.42 – 0.97 oz • inch)
0.15 – 0.53 mN • m
(1.5 – 5.5 g • cm)
(0.021 – 0.076 oz • inch)
more than 5.88 mN • m
(more than 60 g • cm)
(more than 0.83 oz • inch)
more than 5.88 mN • m
(more than 60 g • cm)
(more than 0.83 oz • inch)
Tape Tension Measurement
Mode
FWD
Torque meter
CQ-403A
Meter reading
more than 100 g
(more than 3.53 oz)
SECTION 5
ELECTRICAL ADJUSTMENTS
TAPE SECTION
0 dB = 0.775 V
• Standard Output Level
Output terminal
load impedance
output signal level
HP OUT
32 Ω
0.25 V (–10 dB)
• Test Tape
Type
WS-48A
Signal
3 kHz, 0 dB
Used for
tape speed adjustment
Tape Speed Adjustment
Procedure:
Mode: playback
Adjust so that the value on the digital frequency counter is
3,000 Hz.
digital frequency
counter
test tape
WS-48A
(3 kHz, 0 dB)
32 Ω
set
i jack (J391)
Specification Value:
Digital frequency counter
2,940 to 3,060 Hz
Adjust so that the frequency at the beginning and that at the end of
tape winding are between 2,970 to 3,030 Hz.
Adjustment Location:
Tape speed adjustment
control inside motor
(M971)
20
CFD-G555CP/G555CPK
0 dB = 1 µV
TUNER SECTION
AM IF ADJUSTMENT
Adjust for a maximum reading on level meter.
T1
450 kHz
• AM Section
Setting:
RADIO BAND•AUTO PRESET button: AM
AM RF signal
generator
Put the loop
antenna close to
the set.
level meter
32 Ω
+
–
set
30% amplitude
modulation by
400 Hz signal
Output level:
as low as possible
i jack (J391)
level meter
32 Ω
+
–
set
75 kHz frequency
deviation by 1 kHz
signal
Output level:
as low as possible
TUNER board
TP (GND)
AM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L3
CT3
621 kHz
1,404 kHz
FM IF ADJUSTMENT
Adjust for a maximum reading on level meter.
T2
10.7 MHz
• FM Section
Setting:
RADIO BAND•AUTO PRESET button: FM
TUNER board
FM RF signal
TP-ANT(JW2)
generator
0.01 µF
AM FREQUENCY COVERAGE ADJUSTMENT
Frequency Display
531 kHz
1,611 kHz
Reading on Digital voltmeter
1.0 ± 0.05 V
4.8 ± 0.7 V
Adjustment Part
L4
<confirmation>
i jack (J391)
digital voltmeter
FM FREQUENCY COVERAGE ADJUSTMENT
Frequency Display
Reading on Digital voltmeter
Adjustment Part
87.5 MHz
1.3 ± 0.3 V
<confirmation>
108 MHz
3.0 ± 0.2 V
L2
FM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L1
CT1
87.5 MHz
108 MHz
Adjustment Location: See page 22.
TUNER board
TP (CV)
TP (GND)
•
•
100 k Ω
Repeat the procedures in each adjustment several times, and
the tracking adjustments should be finally done by the trimmer
capacitors.
Remove FM antenna in FM adjustment.
21
CFD-G555CP/G555CPK
Adjustment Location:
L3,CT3
AM TRACKING ADJUSTMENT
– TUNER BOARD (Component Side) –
L1,CT1
FM TRACKNG
ADJUSTMENT
L3
TP-ANT
(JW2)
CT3
L1
CT1
T1
L2
T1
AM IF
ADJUSTMENT
T2
T2
FM IF
ADJUSTMENT
L4
IC1
L2
FM FREQUENCY
COVERAGE
ADJUSTMENT
L4
AM FREQUENCY COVERAGE
ADJUSTMENT
– TUNER BOARD (Conductor Side) –
TP
(GND)
TP
(CV)
TP-ANT
JW2
CD SECTION
Test Point:
– CD/MP3 Board (Side B) –
C742 R724
C743
R701
C703
C750
R722
R723
R745
CNP701
R706
R704
R755
C723
R757
R702
C751
R725
R719
M701
C745
R758 R705
R756 R703
R731
R
CD/MP3 board (side B)
FOCUS BIAS CHECK
1. Connect the oscilloscope between IC701 pin 4 and pin qa
(or TP (RF) and TP (VC)).
2. Insert the disc (YEDS-18). (Part No. : 3-702-101-01)
3. Press the u (CD) button.
4. Confirm that the oscilloscope waveform is as shown in the
figure below. (eye pattern)
A good eye pattern means that the diamond shape ( ) in the
center of the waveform can be clearly distinguished.
R763
CD section adjustments are done automatically in this set.
In case of operation check, confirm that focus bias.
• RF signal reference waveform (eye pattern)
C744
R726
VOLT/DIV : 50 mV (10 : 1 probe in use)
TIME/DIV : 500 nS
R764 C708
C746
R728 R727
IC7
C709
R759
TP TP
(RF) (VC)
C721
C718
C720
C715
C716
C711
C712
C710
R708
22
C719
C707
C704
When observing the eye pattern, set the oscilloscope for AC range
and raise vertical sensitivity.
C706
C717
R709
R729
R710
R711
C740 C713
C701
R707
C705
RF level :
0.85 ± 0.2 Vp-p
R730
Q701
C714
CFD-G555CP/G555CPK
Ver. 1.1
SECTION 6
DIAGRAMS
• Circuit Boards Location
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
For Schematic Diagrams.
Note:
• All capacitors are in µF unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : internal component.
• C : panel designation.
Note:
The components identified by mark 0 or dotted line with mark 0 are
critical for safety.
Replace only with part
number specified.
Note:
Les composants identifiés
par une marque 0 sont critiques pour la sécurité.
Ne les remplacer que par une
piéce por tant le numéro
spécifié.
• H : adjustment for repair.
• A : B+ Line.
• Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions.
– CD/MP3 Board –
no mark : CD PLAY
– TUNER Board –
no mark : FM
(
) : AM
– TC Board –
no mark : FM
(
) : PB
<
> : REC
[
] : CD PLAY
– MAIN Board –
no mark : FM
<
> : CD PLAY
– Other Boards –
no mark : FM
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F
: FM
f
: AM
E
: TAPE PLAY
a
: TAPE REC
J
: CD
N
: MIC (G555CPK)
• Abbreviation
AUS
: Australian model.
CND : Canadian model.
E41
: AC 230 V area in E model.
E92
: AC 120 V area in E model.
MX
: Mexican model.
SP
: Singapore model.
For Printed Wiring Boards.
Note:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
• W : indicates side identified with part number.
•
f
: internal component.
: Pattern from the side which enables seeing.
•
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
POWER board
TUNER KEY board
LED4 board
VOL KEY board
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Indication of transistor.
C
TRANS board
Q
These are omitted.
B E
LED3 board
BATTERY2 board
Q
LED2 board
LCD board
B C E
LED1 board
These are omitted.
BATTERY1 board
Q
B
C
E
These are omitted.
TC board
H/P board
MAIN board
CD/MP3 board
POWER KEY board
(G555CPK only)
TUNER board
MIC board
(G555CPK only)
CD KEY board
CFD-G555CP/G555CPK
23
23
CFD-G555CP/G555CPK
6-1. BLOCK DIAGRAM – CD/MP3 SECTION –
OPTICAL PICK-UP BLOCK
(KSS-213C)
C
C
B
B
D
D
E
E
F
F
8
RF
FIN2
4
3
SLICE
LEVEL
CONTROL
EFMIN
ERROR
CORRECTION
AUDIO CD
PH/BH
7
FIN1
RCHO
9
10
TIN1
FE
TIN2
TE
57
56
ASLRCK
55
APC
D/A
CONVERTER
GENERAL
PURPOSE
PORT
VR
11 VREF
DRF
FSEQ
VREF
TDD
FDD
SPDO
SLDO
VREF
VREF
RF AMP,
SYSTEM SERVO PROCESSOR,
DIGITAL SIGNAL PROCESSOR
IC701
67 31
72 25
66
63 61 62 65 64
CLOCK
GENERATOR
49
48
CMDOUT
CMDIN
CL
CE
INTB
RESB
TD
FD
SP
SL
20 21 22 23
COMMAND
INTERFACE
TRACKING
COIL
T+
T–
17 T+
18 T–
TRACKING
COIL
DRIVE
TIN
FOCUS
COIL
F+
F–
12 F+
11 F–
FOCUS
COIL
DRIVE
FIN
20
10
TD
MP3 DECODER,
CD-ROM DECODER,
ANTI-SHOK
CONTROLLER
IC1001
7 CKIN(I)
54
XOUT
LDS
16MOUT
XIN
79
LDD
DI
CE
CL
WRQ
DO
PD
80
5 CF2IN(I)
9 CKOUT(O)
PLL
VCEC
RES
PD
LD POWER
CONTROLLER
Q701
2 ADDATA(O)
3 ADBCK(O)
4 ADLRCK(O)
CF2
52
FSX/16MIN
50
CONT1
CONT4
LD
MAIN
SECTION
(Page 25)
79 DATA IN
80 DATACK
1 LRSY(I)
ASDACK
SWITCH
FRAME SYNC
DETECT,PROTECT
INSERT
EFM DECODER
A
R-CH
ASDFIN
EXTERNAL
AUDIO IN
A/D
CONVERTER,
SERVO
PROCESSOR
VREF
LD
45
DATA
60
DATACK
59
LRSY
58
AGC
HFL
PH(RFENV)
CD L CH
LPF
SERIAL
OUT
CLV,CAV
CONTROL
42
X701
16.9MHz
FD
73
74
75
76
77
78
CMDOUT
CMDIN
CL
CE
INTB
RESB
MDATA0
I
MDATA15
MADRS0
I
MADRS8
RASB
CASUB
CASLB
OEB
WEB
A
LCHO
8FS
DIGITAL
FILTER
&
1-bit DAC
23-30,33-40
60-53,50
41 44 43 45 42
2-5,7-10,
35-38,40-43
18-21,24-28
16 30 31 29 15
A0-A8
RAS
UCAS
LCAS
OE
WE
A
INTERPOLATION
MUTE
&
ATTENUATION
DEEMPHASIS
MUTE 7
3
SP
SDRAM
IC1002
VREF
23
OPIN 15
VREF
S701
(LIMIT)
S801
PUSH
OPEN/
CLOSE
69 68 70 80 49 79
REG-CHK
74 76 75 50 73
21
58
SYSTEM CONTROLLER
IC801 (1/2)
T901
POWER
TRANSFORMER
CNJ901
78
CD-ON
48 CD-DOOR
F902
72 77
INTB(MP3)
SLED/SPINDLE
MOTOR DRIVER,
TRACKING/FOCUS
COIL DRIVER
IC702
SPIN
DQ0-DQ15
RESB(MP3)
SPINDLE
MOTOR
DRIVE
SL
D901 –904
Q803
AC IN
AC CHK 44
PCON
2
1
25
CMDIN
SP+
SP–
SLIN
CMDOUT
CL
CE
INTB
RESB
M
SP+
SP–
SLED
MOTOR
DRIVE
CMDIN(MP3)
CMDOUT(MP3)
CL(MP3)
CE(MP3)
26 SL+
27 SL–
DI(CD)
CE(CD)
CL(CD)
WRQ(CD)
DI(CD)
SL+
SL–
RES(CD)
M701
SPINDLE
MOTOR
M
DRF(CD)
FSEQ(CD)
M702
SLED
MOTOR
93
CD3.3V
R-ch is omitted due to same as L-ch.
Signal Path
CD1.8V
3
+1.8V
REG
IC1003
1
POWER
CONTROL
Q806,808
+3.3V
REG
Q956
+6V
REG
Q972
+9V
REG
Q971
:CD
3.3V
6V
CD6V
AUDIO 6V
POWER
CONTROL
Q951-953
VDD(SW)
+6V
REG
Q954
U-COM3.3V
3
+3.3V
REG
IC803
U-COM(VDD)
CFD-G555CP/G555CPK
24
24
DRY BATTERY
SIZE " D "
(IEC DESIGNATION R20)
8PCS,12V
2
CFD-G555CP/G555CPK
6-2. BLOCK DIAGRAM – MAIN SECTION –
OVER LOAD
DET
Q351
WOOFER AMP
IC351
9
TAPE MECHANISM DECK
CD/MP3
SECTION
(Page 24)
CD_IN_R
R.IN
8
R.LINE
14
CD_IN_L
L.RO
4
L.LINE
24
A
HRP301
RECORD/PLAYBACK
HEAD
OUT1
VIN1
J391
R-CH
17
12
i
3
MUTE
Q171
22
G555CPK
SP291
SPEAKER
(R-CH)
TU_IN_R
13 14
S971
(PLAY)
TAPE
T301
SP191
SPEAKER
(L-CH)
LOGIC
TAPE 15
16
TU_IN_L
21
U-COM
(VDD)
SC
SI
-2
R.RAD
L.RAD
-1
REC
S301
(REC/PB)
REC
REC BIAS OSC
Q301
S972
(MOTOR)
R-CH
9V
38
35
43
5
19
29 30 31 32 33
6
X801
5MHz
EEPROM
IC802
D401
FREQUENCY
SHIFT
Q812,813
(KARAOKE PON)
TUNER
CONTROL
Q802,811
RADIO 6V
XIN
MO/ST
IF IN
BAND
ST-IND
S1
I
S29
COM1
I
COM4
DO
CE
DI
CL
XOUT
L4
AM IN
FM IN
18 LP-OUT
L4
AM FREQUENCY COVERAGE
D323
CS
DATA
CLK
LCD DRIVER
IC402
1 2 3 4
VDD (SW)
11 12
20
19
13
10
7
8
5-12,14-25,
27-35
1-4
D3
1
53 54 55
AC-HI
REMOTE
CONTROL
RECEIVER
IC891
3
D801
VDD (SW)
45 44 46 47 48
6V
3.3V
PLL
IC2
RMC IN 45
D803
SCK
5
46
WAKE-UP
Q814
1
RESET
IC804
2
RESET
INH
CS
SI
LED
DRIVE
Q817
26 27
LED DRIVE
Q815,816
D402
OPR/BATT
D403-410
(ILLUMIMATION)
KEY3
KEY2
KEY1
KEY FUNCTION
S417-419
S409-416
S401-407
L3
22
AM RF-IN
RADIO 6V
ST-IND
IF
BUFFER
7
D1
D2
FM
IF-IN
: FM
RADIO 6V
L2
FM
FREQUENCY
COVERAGE
DET-OUT
16
FM
DET
10
RADIO 6V RADIO 6V
L2
R-ch is omitted due to same as L-ch.
Signal Path
AF
BUFFER
RADIO 6V
LIQUID CRYSTAL
DISPLAY
LCD401
AM
DET
CF4
FM
RF-OUT FM OSC
24
21
CT1
IF CUT
CF2
2
L1
18
6
FM
OSC
FM
RF-IN
13
AM
IF-IN
T1
FM
MIX
RADIO 6V
L3
AM
FERRITE-ROD
ANTENNA
CT1,L1
FM
TRACKING
MIX-OUT
4
AM
MIX
17
T2
T1
AM
IF
FM
MPX
R-OUT
11
MUTE L-OUT
12
TU_IN_R
: AM
: TAPE PLAY
: TAPE REC
: CD
: MIC
T2
FM
IF
RADIO 6V
CFD-G555CP/G555CPK
25
MPX-IN
15
IF CUT
QUAD
AM
OSC
14
LPF2/MO-ST
AM
OSC
CT3
FM/AM FRONT-END, IF AMP,
FM MPX
IC1
IF-OUT
19
OSC-OUT
20
RADIO 6V
LPF1/BAND
X1
75kHz
CT3,L3
AM
TRACKING
25
M971
CAPSTAN/REEL
MOTOR
TAPE MECHANISM DECK
KEY1
KEY2
KEY3
39
P-MUTE
1 2 3 4
TAPE-PLAY
WOOFER ON/OFF
11
LCD
90 97
A-MUTE
WAKE-UP
V-CLOCK
V-DATA
12
EEPROM
91
LED2
LED1
CD ON
23
TU
WOOFER 1/2
TAPE-ON
RST
INH
96 92
TU_ON
95 94
TU-MUTE
21
RESET
20
FM/AM SHIFT
28 BUF-CTL
A 14
SYSTEM CONTROLLER
IC801 (2/2)
X2
24 CTL-B
98
X1
B 15
16
CE
DATA
CLK
COUNT
ROUT
LOUT
AMP
IC401
25 CTL-C
SCL
LIN
2 MIC
C 16
REC IN
3
SAD
13
MIC_JACK
6
K-LED
9
RIN
M
MIC
CONTROL
Q403,404
ANT1
FM
TELESCOPIC
ANTENNA
POWER AMP
IC371
R-CH
G555CPK
6 REF
R-CH
RV401
MIN
MIC AMP
Q401,402,
405
5
LINE 17
AUDIO 6V
MIC MIX
STANDBY
SW
Q352
RADIO L
G555CPK
J401
8
VOL AMP
20
R.LO 18
5
PB
MIC LEVEL
G555CP
3
L.IN
R-CH
MAX
ALC 2
SP393
WOOFER
5
12
MUTE
Q354
IC321
ELECTRONIC VOLUME
REC/PB
PRE AMP
IC301
DET
L.LO
L-CH
HE301
ERASE HEAD
WOOFER
CONTROL
Q321-323
R.RO
G555CPK
CFD-G555CP/G555CPK
5
6
7
8
9
10
11
12
M702
G555CP
G555CPK
(Page 32)
(Page 33)
IC1003
FB705
R718
R721
C745
R720
C1067
R1003
C1010
R737
Ref. No.
Location
IC701
IC702
IC1001
IC1002
IC1003
F-11
C-8
D-12
D-13
B-12
Q701
F-8
CFD-G555CP/G555CPK
26
26
R1081
R740
C756
C730
C733
C732
R714
R1017
C729
C722
C721
C720
C717
C719
C718
C716
C740 C713
TP
(VC)
C715
C711
C712
C710
R708
• Semiconductor
Location
C701
C705
G
TP
(RF) C714
C707
C704
( )
C706
1
R759
R710
R711
R1018
R1082
FB701
70
R709
R729
C1013
C1011 R1020
FB704
IC
R707
C1037
R1019 C1012
X701 R713
C744
R764 C708
C746
R730
Q701
C1030
R1001
R1002
C766 C1066
R1004
R1005
R734
C1070
C760
FB1001
C767
FB1002
C1074
R732
R735
R722
R723
R733
C763
C751
R725
R719
R763
R745
CNP701
C761 C1069
C764 C1068
C762
R728 R727
F
C1042
R1080
R1079
R765
C709
C1043
C1056
R736
C741
R716
C742 R724
R701
C703
R706
R755
R757
C723
R1078
FB703
R726
C1031
R1076
01
E
C1044
R1077
C750
R702
R704
R1075
C1055
10
R756 R703
M701
D
C743
C1057
C1029
IC
R758 R705
R717
R731
S701
C754
C753
C1058
C1001
C702
R753
C737
C748
C747
IC702
R712
C
R760
C1110
3
R1074
C1059
R1073
R1068
FB706
FB707
1
R743
R744
14
CNP702
FB702
B
C734
C731
A
13
C1054
4
IC1002
3
:Uses unleaded solder.
R766
C1014
2
•
R761
1
• See page 23 for Circuit Boards Location.
R715 R762
6-3. PRINTED WIRING BOARD – CD SECTION –
( )
CFD-G555CP/G555CPK
• See page 42 for Waveforms. • See page 42, 43 for IC Block Diagrams.
• See page 45 for IC Pin Function Description.
C753
C1057
C1058
R721
R722
R719
R720
R726
R729
R725
R724
C708 R730
R716
S701
C1056
C1001
R717
R718
C744
C746
C743
R731
R728 R727
R1076
R1075
R1074
C754
C709
R1078
6-4. SCHEMATIC DIAGRAM – CD SECTION –
C1059
IC1003
C741
C760
C761
C751
C742
R1080
R1073
R764
C723
C710
R1068
C762
C763
C1044
C705
C714
C1069
C1070
C1066
C711
C712
C1067
C1068
C713
C764
C766
R759
C1042
C1043
R723
R732
R708 R711
C1110
R733
R734
R709 R710
C750
C704
R763
C703
Q701
R1079
R1077
C745
R707
R1001
R735
R1002
R736
R737
R1003
R1004
FB703
R1005
C767
FB1001
CNP701
C701
IC701
C1074
FB704
FB1002
LC78646E-US-E
X701
C715
R701
C716
R702
R703
R755
R756
R704
R705
R757
R758
C717
IC1001
LC78684E-US-E
R713
C718 C707
C740
C1031
C1010
R765
FB701
C706 C719 C720
R715
R762
R706
C721
R761
R714
C
R1017 R1081
R745
C730 220
C733
C732
C1030
R1020
C1014
C737
C1029
C1037
C1012 R1082 R1018
C1013
C729 2200 10V
C722
R740
C702
C1011
R766
R1019
IC B/D
6.3V
C756
SL701
SL702
SL703
SL704
CNP702
C1054
C1055
R760
R753
3
CNP802
(Page 35)
C734
C731
IC1002
MSM54V162588
BSL-40TSK
IC B/D
IC702
FB702
FB705
FB706
FB707
R743
R712
M702
C747
C748
no mark : CD PLAY
M701
R744
CFD-G555CP/G555CPK
27
27
CFD-G555CP/G555CPK
6-5. PRINTED WIRING BOARD – TUNER SECTION –
1
2
•
• See page 23 for Circuit Boards Location.
3
4
5
6
:Uses unleaded solder.
7
8
9
10
11
12
13
14
A
ANT1
FM TELESCOPIC
ANTENNA
L3
AM FERRITE BAR ANTENNA
D10
C32
L3
R63
C29
JW13
D1
L1
JC24
R5
C1
C33
R1
R30
C42
C41
JW8
T1
D3
R40
CT1
R2
X1
R4
JC6
JW11
C18
IC1
C24
C11
R31
R33
L2
C31
C20
C7
R92
C22
TP
(GND)
C14
C15
C12
C77
C66
R11
JW7
R91
JC5
JC34
CF2
T2
C54
C68
G
C9
R14
C57
C60
C80
R24
C23
C21
R13
CF4
JC4
R54
C95
C55
R94
C30
JW9
R53
R58
G555CP:E92/
G555CPK
C13
C56
C39
F
JC33
L4
JC3
R55
R51
C59
JW10
C63
R59
C53
IC2
R60
JW6
C52
C51
C62
R61
R52
C61
MAIN
BOARD
FFC11
(Page 33)
C37
C43
L21
R50
CNP1
R57
R56
D2
G555CPK
E
C10
SP,E41,AUS
C49
C27
C
R41
R3
JC13
JC2
G555CP
MAIN
BOARD
FFC11P
(Page 32)
TP
(CV)
C8
JW12
R65
CT3
C47
JC1
JW4
C26
R10
D
C4
C35
L11
JW14
C65
JW3
R32
C
C34
G555CP:E92/
G555CPK
JW2
JW5
JC12
D11
JC11
B
C78
SP,E41,AUS
1-863-438-
• Semiconductor
Location
Ref. No.
D1
D2
D3
D10
D11
Location
C-10
D-8
D-8
B-12
B-12
IC1
IC2
E-10
F-4
CFD-G555CP/G555CPK
28
28
11
(11)
CFD-G555CP/G555CPK
• See page 42 for Waveforms.
6-6. SCHEMATIC DIAGRAM – TUNER SECTION –
• See page 43 for IC Block Diagrams.
R91
C51
L3
D3
C52
C53
C54
R51
R54
R52
C41
C56
L4
C42
IC B/D
CT3
R41
C49
X1
R55
R53
C43
JC11
0
JC12
0
C57
C59
R50
R40
C95
C55
C47
C39
7
C32
C37
IC2
R32
C13
JC3
R4
0
R14
C30
C24
R33
R31
L2
L1
G555CP:
E92/
G555CPK
JC5
0
C31
CT1
C34
C80
D2
C33
D1
C35
R30
R11
R24
C22
C61
C20
C62
C63
R61
R60
C60
R94
R58
R13
C68
SP,E41,AUS
C23
JC24
C21
R59
C66
R92
L11
JC4
0
G555CP:E92/
G555CPK
R56
R57
L21
IC1
ANT1
CNP1
IC B/D
JC2
R10
0
JC33
C1
0
C11
C12
C9
JC34
C7
R65
C29
C26
0 JC13 T1
SP, E41
AUS
T2
CF4
C78
C8
D11
D10
R3
JC6
C10
C4
R1
C77
0
R5
no mark : FM
(
) : AM
CF2
C18
C14
C15
*
*
*
: G555CP:E92/G555CPK
: SP, E41, AUS
CFD-G555CP/G555CPK
29
29
C27
C65
0
R2
C
JC1
0
R63
3
FFC11P
(Page 35)
CFD-G555CP/G555CPK
6-7. PRINTED WIRING BOARD – TC SECTION –
• See page 23 for Circuit Boards Location.
1
2
•
:Uses unleaded solder.
3
4
5
6
7
A
T301
Q301
C305
B
C307
R307
R308
C304
R306
JC304
CN303
R302
JC301
R211
C205
R303
G555CP
B
R106
C302
PB
C102
JC306
JC305
JC308
JC307
R101
R111
C105
C101
R104
JC302
KHP805
( Page 33 )
R309
R105
R112
C103
R103
R301
C301
C303
C107
R102
R110
C104
R304
E
BLK
BLK
WHT
RED
YEL
1-688-389-
F
(CHASSIS)
R-CH
L-CH
HRP301
RECORD/PLAYBACK
HEAD
G
KHP805
( Page 32 )
G555CPK
R210
D
JC303
R205
R212
R204
C204
C207
R206
C201
C203
R203
R315
S301
-2
-1
IC301
R201
S301
(REC/PB)
REC
R202
C202
C
R314
R305
C306
HE301
ERASE HEAD
TAPE MECHANISM DECK
CFD-G555CP/G555CPK
30
30
11
(11)
CFD-G555CP/G555CPK
6-8. SCHEMATIC DIAGRAM – TC SECTION –
• See page 42 for Waveforms. • See page 44 for IC Block Diagram.
IC301
R103
R301
C102
TAPE MECHANISM DECK
C301
9
R112
IC B/D
R102
R111
R104
C103
C104
C101
JC302
C107
R110
R101
C105
JC306
JC305
C303
C302
JC308
JC307
R309
R201
C205
C207
C201
R211
C203
R204
R203
R212
R304
R210
C204
CN303
C202
R202
R105
JC303
R106
R206
R205
JC301
R303
3
KHP805
R302
R305
R314
T301
R315
(Page 35)
JC304
8
R306
C305
Q301
R308
C306
C304
C307
CFD-G555CP/G555CPK
31
31
R307
no mark : FM
(
) : PB
<
> : REC
[
] : CD PLAY
CFD-G555CP/G555CPK
6-9. PRINTED WIRING BOARDS – MAIN SECTION (G555CP) – • See page 23 for Circuit Boards Location.
1
2
3
4
5
•
:Uses unleaded solder.
6
7
8
9
CD KEY
BOARD
KH401
(Page 37)
LCD
BOARD
FFC11P
(Page 37)
A
10
11
12
TUNER KEY
BOARD
KH402
(Page 37)
• Semiconductor
Location
S801
R294
B
SP191
(L-CH)
R293
3
SPEAKER
C823
1-869467-11
IC802
1
4
L804
A
IC802
K
IC804
E
R809
R892
X801
80
IC
JW397
JW834
1-869-467-
1
R877
C830
R878
R854
E
C124
JW817
E
JW306
R897
JW853
TC
BOARD
CN303
(Page 30)
D
C857
R832
R831
R845
JW399
C856
JW828
KHP805
C123
TUNER
BOARD
CNP1
(Page 28)
1
R881
JW816
C
FFC11P
11
JC302
3
8
JW837
1
5
E
E
C861
4
R824
E
5
C860
JW395
R346
11
11
C817
A
SP393
(WOOFER)
1
2
L807
SP291
(R-CH)
R874
JW367
JW852
Ref. No.
Location
D320
D321
D322
D323
D325
D351
D801
D803
D805
D806
D951
D952
D954
D955
D956
G-10
H-10
G-10
F-7
F-11
G-9
B-7
B-7
D-10
D-10
G-8
G-8
G-8
G-8
G-9
IC321
IC351
IC371
IC801
IC802
IC803
IC804
E-7
H-9
H-5
C-9
B-10
E-8
C-8
Q171
Q271
Q321
Q322
Q323
Q351
Q352
Q354
Q802
Q803
Q806
Q808
Q811
Q812
Q813
Q814
Q815
Q816
Q951
Q952
Q953
Q954
Q956
Q971
Q972
H-5
H-5
G-11
F-11
F-11
G-10
H-9
G-10
E-9
C-7
E-8
E-8
E-8
C-8
C-8
C-7
D-9
D-9
F-8
G-7
F-7
G-9
G-10
H-6
H-8
E
C148
E
Q802
IC803
IC321
E
19
JW309
E
E
R862
JW822
1
3
20
JW307
C853
C343
6
A
A
K
C350
1
S972
MOTOR
CNP303 5
F
JW331
POWER
BOARD
KH903
(Page 39)
S971
PLAY
CD/MP3
BOARD
CNP702
(Page 26)
JW899
G
M971
CAPSTAN/REEL
MOTOR
C340 E
R334
E
C337
E
E
R331
E
E Q351
A
K
C326
JW325
C327
R127
R227
R365
R960
C958
K
R950
K
R952
G
E
A
K
R953
A
K
C132
D351
C358
Q354
R359
D320
C336
A
K
C357
A
KH353
E
JW319
JW320
C355
C338
C366
R323
R351
R356
R357
C352
IC351
5
E
10
E
15
1
11
E
E
H
IC371
R322
E
(11)
1-869-464-
I
CFD-G555CP/G555CPK
32
32
CFD-G555CP/G555CPK
• See page 23 for Circuit Boards Location.
6-10. PRINTED WIRING BOARDS – MAIN SECTION (G555CPK) –
1
2
3
4
5
•
:Uses unleaded solder.
6
A
7
8
9
CD KEY
BOARD
KH401
(Page 38)
LCD
BOARD
FFC11P
(Page 38)
MIC BOARD
CNP394
(Page 38)
10
11
12
TUNER KEY
BOARD
KH402
(Page 38)
• Semiconductor
Location
KH354
C419
C435
R432
E
R293
Q402
L807
IC802
R884
R816
R292
11
11
1
IC401
E
1
5
8
L804
K
IC804
5 4
1
E
E
E
JW388
JW829
3
1-869-446-
C
4
1
FFC11P
11
R809
SP393
(WOOFER)
A
A
2
L806
JC309
L301
Q812
H/P
1-869446-11
JW394
E
4
E
C823
E
1
1
2
1
4
R347
4
SP291
(R-CH)
C417
SP191
(L-CH)
SPEAKER
JW803
B
S801
CNP806
E
R460
R294
R842
R869
E
80
IC
1
JW828
1
C830
C829
JW817
E
R897
E
JW367
R878
R871
JW816
JW853
R254
R154
R845
R832
JW306
R859
11
D
C857
R831
KHP805
TC
BOARD
CN303
(Page 30)
TUNER
BOARD
CNP1
(Page 28)
1
R881
JW852
R874
1
3
E
C148
JW309
E
JW310
E
E
IC803
IC321
E
C846
A
JW331
CD/MP3
BOARD
CNP702
(Page 26)
G
JW336
POWER
BOARD
KH903
(Page 40)
S971
PLAY
S972
MOTOR
A
CNP303
F
A
K
C350
M971
CAPSTAN/REEL
MOTOR
R334
E
E
K K
E
R365
R950
G
JW325
K
A E
Q351
C231
E
E
R227
K
E
E
R960
K
C175
A
C953
A
D954
E
C132
D320
Q354
C353
C359
C336
C358
KH353
A
A
K
E
JW320
R351
IC351
5
E
10
1
15
10
5
1
H
E
15
IC371
R322
C366
C355
E
E
11
E
1-869-443-
I
CFD-G555CP/G555CPK
33
33
(11)
Ref. No.
Location
D320
D321
D322
D323
D325
D351
D801
D803
D805
D806
D951
D952
D954
D955
D956
G-10
H-10
G-10
F-7
F-11
G-9
B-7
B-7
D-10
D-10
G-8
G-8
G-8
G-8
G-9
IC321
IC351
IC371
IC401
IC801
IC802
IC803
IC804
E-7
H-9
H-5
C-5
C-9
B-10
E-8
C-8
Q171
Q271
Q321
Q322
Q323
Q351
Q352
Q354
Q401
Q402
Q403
Q404
Q405
Q802
Q803
Q806
Q808
Q811
Q812
Q813
Q814
Q815
Q816
Q817
Q951
Q952
Q953
Q954
Q956
Q971
Q972
H-5
H-5
G-11
F-11
F-11
G-10
H-9
G-10
B-5
B-5
B-5
B-5
C-5
E-9
C-7
E-8
E-8
E-8
C-8
C-8
C-7
D-9
D-9
B-10
F-8
G-7
F-7
G-9
G-10
H-6
H-8
CFD-G555CP/G555CPK
• See page 44 for IC Block Diagram.
R364
IC351
BA5417
IC321
BD3870FS-E2
R335
22k
C340
100 10V
R361
2.2k
C355
100 10V
C354
100 10V
C353
100 10V
C351
100 10V
C352
0.1
R357
470
Q354
KTC3203Y-AT
R353
4.7k
D321
1SS355TE-17
100p
C366
R328 1k
R175
220
2.2k
R273
2.2k
Q271
2SC3052EF
C272
470p
C172
470p
R275
220
C173
100 10V
R372
10k
C274
1000 10V
R371
10k
C346
1000 25V
R276
100
R181
4.7
KH354
3P
C435
100p
1000p
C434
S972
CFD-G555CP/G555CPK
34
34
C951
0.022
Q953
DTC143EUA
Q951
DTC123JUA
MC2836
D951
0.1
C436
C343
MC2836
2.2k
R948
S971
R943
2.2k
C348
4700 25V
C954
220 10V
R944
2.2k
D952
2.2k
R947
0
2.2k
R957
100
C957
220 10V
D954
UDZSTE-1710B
D955
UDZSTE-176.8B
C955
0.022
R942
2.2k
R955
100
CNP303
6P
M971
R941
2.2k
R307
2.2k
R946
2.2k
R949
R945
2.2k
2.2k
R952
R950
2.2k
R953
R958
1k
C961
220 10V
C960
220 10V
D956
UDZSTE-173.9B
C349
220 25V
C350
0.022
R951
100k
C972
0.1
R964
100
C958
0.022
2.2k
R342
D323
1SS355TE-17
R965
470
2.2k
R343
1k
Q952
KTA1266GR
Q971
KTD2058Y
1k
R348
R341
Q972
KTD2058Y
C953
0.022
R960
100
R194
220
C402
1
50V
C408
0.047
RV401
10k
10 50V
Q954
KTC3198GR-AT
R961
1k
C381
220 10V
CNP394
3P
L303
C336
R176
100
C175
0.1
L304
C959
0.022
220
L302
C275
0.1
1k
Q956
KTC3203Y-AT
R193
C174
1000 10V
R281
4.7
220 10V
R173
R278
1k
C371
100 10V
C276
0.01
C273
100 10V
10k
C271
47 10V
10V
0.01
100
C339
0.022
C334
C341
22 25V
R339
CNP391
9P
R178
1k
R272
C301
220
10V
J391
220
R294 220
10k
Q171
2SC3052EF
D325
MC2838
10k
R252 4.7k
BA5417
KH373
4P
C176
0.01
R172
Q323
RT1N144C-TP-1
10K/47K
R251
4.7k
10k
R151
IC371
C171
47 10V
C223
2.2
50V
R152
SP291
R293
R340 1k
R329
2.2k
R330
470
C123
2.2
50V
R360
10
10k
D322
1SS355TE-17
C333
0.1
100
C329
C324
10V
0.1
C224
1000p
C122
0.1
0.1
R223
4.7k
R359
10
SP191
KH353
5P
R292 1k
R334
470
R325
2.2k
C222
C124
1000p
C361
0.01
C358
0.1
Q352
DTA143ZUA-T106
2.2k
50V
50V
C328
R123
4.7k
CNP392
4P
C357
0.1
R338
4.7
4.7
R363
220
1k
R366
C342
100p
R337
22k
C247
R356
C356
100 10V
R362
1k
R336
10k
Q321
2SC3052EF
C147
CNP393
4P
R192
R333
10k
R323 1k
C326
0.047
R332
470k
0.022
R331
22k
C327
C337
1 50V
Q322
2SC3052EF
R326 1k
10k
R127
10k
R134
470k
R227
R234
470k
50V
0.47 50V
R351
4.7k
D320
MC2838
R344 4.7k
C130
C129
C230
C229
C227
4700p
C127
4700p
C323
C231
50V
SP393
R322 1k
10 50V
2.2
1M
Q351
KTC3198GR-AT
R224 2.2k
C338
C360
R365
C359
22 25V
2.2k
R228
R124 2.2k
0.47 50V
2.2k
470p
C321
C131
R128
470p
R125
4.7k
C322
R225
4.7k
C325
C132
C232
100p
100p
10V
D351
MC2840
1M
1k
6-11. SCHEMATIC DIAGRAM – MAIN SECTION (1/3) –
CNP301
5P
R426
1k
J401
C414
4700p
CFD-G555CP/G555CPK
• See page 42 for Waveform.
6-12. SCHEMATIC DIAGRAM – MAIN SECTION (2/3) –
• See page 47 for IC Pin Function Description.
KHP805
11P
R884
220
R885
220
2.2
C126
50V
2.2
Q802
RT1P144C-TP-1
10K/47K
C226
R346
470
C830
100p
100p
C828
100p
R253
4.7k
R153
4.7k
C857
C817
0.1
D803
UDZSTE-175.1B
R866
10
L809
C846
0.1
C805
10
50V
Q808
RT1N144C-TP-1
10K/47K
C801
47 10V
R839
47k
100p
R835
470
D806
1SS355TE-17
Q815
RT1P144C-TP-1
10K/47K
1k
R871
470
D805
1SS355TE-17
R878
470
4.7k
4.7k
R874
R873
R875
R876
R832 10k
100k
4.7k
R899
100
R898
100
R801
1k
R802
1k
R861
100
R803
1k
R845
1k
R804
1k
R805
1k
R859
1k
R806
1k
R858
1k
R807
1k
R857
1k
R808
1k
R856
1k
R855
1k
R809
1k
R810
1k
R862
R860
1k
R811
IC801
L807
100
100p
100p
100p
C837
100p
C838
100p
1k
C803
1000p
1k
R460
47k
4.7k
1k
R818
220
R819
220
R838
4.7k
R837
4.7k
R863
CNP804
*
1k
R864
1k
G555CP
4.7k
R840
4.7k
R849
R836
4.7k
1k
2SA1577
10k
R847
1k
R895
R894
1k
R848 4.7k
R893
Q817
R891
10k
R841
100p
1k
100p
1k
R817
C852
R868
JC310
0
R870
5MHz
C802
100p
47k
Q814
DTA144TUA
C863
0.01
CFD-G555CP/G555CPK
35
220k
10p
22p
C821
C860
1
R834 1k
FB801
HB-1B1608-222JT
35
100p
R880
22p
C859
Q812
2SC3052EF
R833
22p
Q813
2SC3052EF
10p
C862
0.01
C832
100k
C861
22p
C820
R824
1k
10k
JC391
R825
10k
0.1
C856
C854
100 10V
C855
10 50V
L802
1k
R850
C864
L804
0.01
100
R869
22k
C858
C853
1k
R830
IC804
BD4826G
R867
R831
R879
G555CPK
R828
4.7k
X801
C869
0.1
1k
470
C804
0.01
R826
1k
R823
220
R822 220
R820 220
100
R872
IC803
S-812C33AUA-C2NT2G
R821
100
R459
G555CPK
L803
1k
L805
C834
C836
R815
R896
L806
100p
R890
47k
100
100
C835
1k
R816
R854
1k
R814
S801
CNP801
11P
R827
47k
R843
IC802
CAT24WC02JI-1.8
-TE13
KH851
2P
1k
R853
R852
-561-3BA-A
R842
G555CP:E92/G555CPK
100
C851
R883
100k
0
0
100k
JC304
JC306
0
100p
C845
JC309
0.01
100p
C843
C844
100p
1000p
1000p
C842
1000p
C840
C841
4.7k
R892
10k
R154
10k
JC302
47K
C839
CNP802
20P
Q816
KTA1266GR
R254
10k
R882
10k
R829
C833
100p
R897
10
R851
10k
1 50V
100p
C827
47K
47K
C826
C151
10
50V
R881
1 50V
100p
R846
C850
Q811
RT1N144C-TP-1
10K/47K
R889
47k
C825
C251
10
50V
FFC
11P
C148
R347
470
R865
100k
100p
C824
R877
10k
JC305
Q806
2SA1577
C823
100 10V
C829
100p
C248
R887
47k
R888
470
TUNER
CONTROL
JC303
Q803
RT1N144C-TP-1
10K/47K
R886
220
D801
KDS121-RTK
50V
0
CNP806
2P
CFD-G555CP/G555CPK
6-13. SCHEMATIC DIAGRAM – MAIN (3/3), CONTROL SECTION –
LCD401
R427
2.2k
IC891
RPM7140-V4
FFC
11P
L401
R428
470
R469
100k
R443
2.2k
C403
1 50V
D402
L-7104SRD-H
C440
C444
1
50V
R475
220k
C441
47p
47p
C439 47p
C438 47p
IC402
NJU6533FA2
100
100
R420
22k
S416
R449
R448
R419
2.2k
S415
100
R450 100
R418
4.7k
S414
C404
0.01
R451 100
R444
R417
1k
R416
2.2k
C437 47p
KH404
2P
R461 2.2k
C406
1
50V
R462 2.2k
R463 2.2k
R452
220k
R442
47k
R464 2.2k
KH403
2P
R465 2.2k
R445
470k
R411
470
R412
220
R413
1k
R414
1k
R415
2.2k
S413
S412
S411
S410
S409
KH402
2P
CNJ401
2P
CNJ402
2P
R471
220
D403 L-7104SRD-H
CNJ403
2P
CNJ404
2P
R473 220 D405 L-7104SRD-H
R474 220
R472 220 D404 L-7104SRD-H
CNJ405
2P
CNJ406
2P
R476 220
R477 220
D406 L-7104SRD-H
D407 L-7104SRD-H
CNJ407
2P
CNJ408
2P
R456 1k
R478 220 D409 L-7104SRD-H
D410 L-7104SRD-H
C418
4.7
50V
C433
100p
C432
100p
S419
C152 1 50V
IC401
BA3837
R423
470
C423
22
25V
CFD-G555CP/G555CPK
36
36
R424
220
R403
1k
R404
1k
R405
2.2k
R406
2.2k
R407
1k
S407
R453
470
S406
C422
47
10V
S405
R446
470
S404
R432
1k
Q403
DTC114YUA
KH401
*
C424
10 50V
S403
C421
1 50V
S418
C154
220p
S417
R431
470k
S402
R421
0
C253 10 50V
R434
1k
R433
47k
R430
47k
R422
1k
C252 1 50V
C416
100
10V
C415
2200p
R402
220
C153 10 50V
R429
2.2k
C431
100p
R401
470
R441
220k
Q405 2SC3052EF
C420
47
10V
R421
1k
S419
C419
100
10V
Q402
2SC3052EF
Q401
2SC3052EF
JC401
0
C254
220p
S401
C417
4.7
50V
R422
1k
S402
S401
R438
1k
R435
4.7k
R402
220
KH405
3P
C425
0.22
R440
470
R437
1k
R401
470
C426 0.22
R454
47k
R439
470
R436
2.2k
D401 L-34HD
R457 4.7k
R479 220
D408 L-7104SRD-H
R455
47k
Q404
DTA114YUA
R458 220
R408
4.7k
R409
2.2k
CFD-G555CP/G555CPK
6-14. PRINTED WIRING BOARDS – CONTROL SECTION (G555CP) – • See page 23 for Circuit Boards Location.
•
:Uses unleaded solder.
CD KEY BOARD
P0WER
MODE
WOOFER
KH401
-
3
SLEEP
+
FOLDER
-
PRESET
+
1-869-470-
11
11
F
MAIN
BOARD
CNP804
(Page 32)
MAIN BOARD
CNP801
(Page 32)
E
LCD BOARD
TUNER KEY BOARD
FFC11P
11
1
DISPLAY
ENTER
MEMORY
S409
LCP401(LIQUID CRYSTAL DISPLAY)
1
33
OPR/BATT
IC891
R415
R413
KH402
JW405
KH403
S411
1-869-471-
11
11
JW404
14
13
R469
TUNE +
R412
JW407
D
L401
1
IC
26
52
2
40
27
R445
R442
R452
C444
C441
C437
C439
40
39
R448
R450
C438
JW410
R464
R444 R465
MAIN
BOARD
CNP806
(Page 32)
R443
C440
C403
R414
R411
JW406
R427
R475
1
JW409
R451
VOL KEY BOARD
R463
R449
JW403
CNJ401
C406
R462
1
REPEAT
TUNE -
R428
3
JW408
RADIO BAND
S412
2
11
11
R461
1-869-461-
SOUND
CNJ403
1-869-473-
CNJ404
CNJ405
1-869-474-
CNJ406
9
7
CNJ407
11
11
1-869-475-
CNJ408
1-869-476-
CFD-G555CP/G555CPK
37
VOL
-
10
R478
8
11
11
R476
6
R477
R474
5
11
11
LED 4 BOARD
LED 3 BOARD
R479
CNJ402
3
R471
R472
4
LED 2 BOARD
R473
LED 1 BOARD
KH404
VOL +
37
11
11
1-869-472-
11
11
• Semiconductor
Location
Ref. No.
Location
D402
D403
D404
D405
D406
D407
D408
D409
D410
F-5
J-6
J-5
J-7
J-8
J-9
J-9
J-10
J-11
IC402
IC891
H-5
F-5
CFD-G555CP/G555CPK
6-15. PRINTED WIRING BOARDS – CONTROL SECTION (G555CPK) –
• See page 23 for Circuit Boards Location.
•
:Uses unleaded solder.
HK405
CD KEY BOARD
WOOFER
1
-
4
+
FOLDER
-
F
POWER KEY BOARD
MAIN BOARD
CNP801
(Page 33)
DISPLAY
ENTER
MEMORY
S409
LCD BOARD
RADIO BAND
S412
REPEAT
R414
TUNE -
R415
R412
KH402
KH403
S411
D401
1-869-452-
FFC11P
11
11
11
P0WER
LCP401(LIQUID CRYSTAL DISPLAY)
R428
R475
3
1
JW409
JW406
JW405
JW407
MAIN BOARD
KH354
(Page 33)
14
L401
1
52
2
40
3
C437
R448
JW410
R451
VOL
R463
JW403
CNJ401
C406
R462
1
2
11
11
R461
1-869-447-
1-869-461-
LED 1 BOARD
CNJ402
LED 2 BOARD
5
CNJ403
11
11
1-869-454-
CFD-G555CP/G555CPK
38
1-869-453-
3
R471
R472
4
J401
MIC MIX
-
R449
38
CNJ404
6
8
CNJ405
11
11
1-869-455-
CNJ406
9
7
CNJ407
11
11
1-869-456-
11
11
LED 4 BOARD
LED 3 BOARD
CNJ408
10
R479
R464
R478
C403
40
39
11
11
C439
R450
C438
R444 R465
VOL +
C441
R476
27
SOUND
C444
C440
KH404
IC
26
R443
R445
R442
R452
R477
MIC BOARD
JW404
13
R469
VOL KEY BOARD
JW408
MIC LEVEL
MAIN
BOARD
CNP806
(Page 33)
OPR/BATT
IC891
1-869-450-
H
D
1
33
R473
MODE
R474
KARAOKEPON
11
11
1
R427
R458 R457
R456
KARAOKEPON
S419
TUNE +
R413
R411
1
3
11
11
1-869-451-
TUNER KEY BOARD
MAIN
BOARD
CNP804
(Page 33)
E
+
PRESET
1-869-457-
11
11
• Semiconductor
Location
Ref. No.
Location
D401
D402
D403
D404
D405
D406
D407
D408
D409
D410
E-3
F-10
J-10
J-10
J-11
J-12
J-13
J-13
J-15
J-15
IC402
IC891
H-9
F-9
CFD-G555CP/G555CPK
6-16. PRINTED WIRING BOARD – POWER SECTION (G555CP) –
1
2
3
• See page 23 for Circuit Boards Location.
4
5
•
:Uses unleaded solder.
6
7
8
9
10
11
A
B
BATTERY 1 BOARD
BATTERY 2 BOARD
POWER BOARD
C
AC IN
C904
CNJ901
G
D
11
1-869-465-
E
MAIN BOARD
CNP301
( Page 32)
(11)
DRY BATTERY
SIZE " D"
( IEC DESIGNATION R20 )
8PCS, 12V
TRANS BOARD
T901
POWER TRANSFORMER
F
G
replaceable :
* Not
Built in transformer
*
11
11
1-869-468-
(11)
1-869-466-
H
I
CFD-G555CP/G555CPK
39
39
(11)
1-869-469-
11
(11)
12
CFD-G555CP/G555CPK
6-17. PRINTED WIRING BOARD – POWER SECTION (G555CPK) –
1
2
3
• See page 23 for Circuit Boards Location.
4
5
•
:Uses unleaded solder.
6
7
8
9
10
11
A
B
BATTERY 1 BOARD
BATTERY 2 BOARD
POWER BOARD
C
AC IN
C904
CNJ901
G
D
11
1-869-444-
E
MAIN BOARD
CNP301
( Page 33)
(11)
DRY BATTERY
SIZE " D"
( IEC DESIGNATION R20 )
8PCS, 12V
TRANS BOARD
T901
POWER TRANSFORMER
F
G
replaceable :
* Not
Built in transformer
*
11
1-869-445-
11
1-869-448-
(11)
H
I
CFD-G555CP/G555CPK
40
40
(11)
1-869-449-
11
(11)
12
CFD-G555CP/G555CPK
6-18. SCHEMATIC DIAGRAM – POWER SECTION –
G
1 3
(Page 34)
KH903
5P
C903 0.022uF
JW906
D903
1N5401M
D904
1N5401M
JW912
C904
0.022uF
JW911
CFD-G555CP/G555CPK
41
41
CNP902
4P
KH941
4P
JW941
JW942
JW954
JW918
JW943
C902 0.022uF
F902
JW905
JW952
D902
1N5401M
JW919
JW944
JW903
BATTERY 2
JW953
D901
1N5401M
JW904
CNJ901
C909
2200
25V
JW951
BATTERY 1
C901
0.022uF
CFD-G555CP/G555CPK
IC801 ek (X2)
IC701 LC78646E-US-E
80 79
78 77 76 75 74 73 72 71 70 69 68 67 66
500 mV/DIV, 5 µs/DIV
500 mV/DIV, 0.5 µs/DIV
+
–
+
–
IC701 qd (FE)
1.8 V
TIN1
– TC Board –
8
TIN2
Q301 C (REC)
Approx. 100 mVp-p
3
WRQ
DO
DI
CL
CE
WRQ
DO
DI
CL
CE
PH
EQ
AGC
BH
LPF
+
–
TBAL
+
–
TBAL
LPF
SW
+
–
LPF
+
–
+
–
RFMON
LEVEL SET
REFI
100 mV/DIV, 200 µs/DIV
MIX
RF
FIN1
1 V/DIV, 100 ns/DIV
FIN2
2
DRF
4.2 Vp-p
200 ns
TEC
1.5 Vp-p
65 64 63 62 61
TE
13.3 µs
FE
0.85 ± 0.2 Vp-p
VSS
VDD5
DRF
RES
FR
VVDD
PCKIST
VVSS
PDO2
PDO1
CONT1
CONT2
CONT3
0
IC2 w; (XOUT)
– CD/MP3 Board –
FR
VVDD
PCKIST
VVSS
PDO2
PDO1
CONT1
CONT2
CONT3
7
IC701 4 (RF)
– MAIN Board –
LDD
LDS
1
• IC Block Diagrams
– TUNER Board –
LDD
LDS
• Waveforms
– CD/MP3 Board –
MONI
CONT
–
+
VREF
RAM
DEFECT
4 Vp-p
IC701 qg (TE)
19.5 µsec
TRACK JUMP
1.8 V
1 V/DIV, 5 µs/DIV
9
ADAVDD
ADAVSS
TDO
JITTC
SLCO
SLCIST
EFMIN
RF
RFVDD
RFVSS
FIN1
FIN2
TIN1
TIN2
VREF
REFI
FE
TEC
TE
RFMON
JITTC
ADAVDD
ADAVSS
TDO
40 Vp-p
19.5 µsec
10 V/DIV, 5 µs/DIV
6 Vp-p
59 ns
1 V/DIV, 50 ns/DIV
IC701 t; (FSX/16MIN (1))
SLCO
1
SLCIST
2
EFMIN
3
RF
4
5
6
FIN1
7
FIN2
8
TIN1
9
TIN2
10
VREF
11
REFI
12
FE
13
TEC
14
TE
15
RFMON
16
JITTC
17
ADAVDD
18
ADAVSS
19
TDO
20
JITTER
DETECT
SW
SLICE LEVEL
CONTROL
DRF
RUPTURE DEFECT
PDO1
PDO2
FR
PLL
PCKIST
VCEC
VVDD
VVSS
FRAME SYNC
DETECT,PROTECT,INSERT,
EFM DECODE
CLV,CAV
CONTROL
SBCK/FG
FSEQ
V/P
SUBCODE DECODE CRC
16MOUT
XVSS
XIN
XOUT
XVDD
CLOCK
GENERATOR
WRQ
CL
CE
DI
DO
SBCK/CONT6
CONT4,5
MONITOR SIGNAL SELECTOR
MONI1-5
RAM
COMMAND
INTERFACE
EFLG
C2F
FSX/16MIN
ERROR
CORRECTION
AUDIO CD
GENERAL PURPOSE
PORTS
INTERPOLATION
MUTE
6 Vp-p
8FS
DIGITAL FILTER
2 V/DIV, 50 ns/DIV
ATTENUATION
DEEMPHASIS
EXTERNAL
AUDIO IN
ASDFIN
ASDACK
ASLRCK
SERIAL
OUT
DATA
DATACK
LRSY
AUDIO OUT
IC1001 7 (CKIN (1))
1BIT DAC
LVDD
LVSS
LCHO
RCHO
RVDD
RVSS
LPF
FDO
SPDO
SLDO
GPDAC
CONT4
CONT5
SBCK/CONT6
SBCK/FG
DEFECT
V/P
FSEQ
MONI1
MONI2
MONI3
MONI4
MONI5
6
FDO
SPDO
SLDO
GPDAC
DRF
CONT1-3
60 ns
S/H
D/A
7 Vp-p
60 ns
FDO
SPDO
SLDO
GPDAC
CONT4
CONT5
SBCK/CONT6
SBCK/FG
DEFECT
V/P
FSEQ
MONI1
MONI2
MONI3
MONI4
MONI5
VSS
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
2 V/DIV, 50 ns/DIV
CFD-G555CP/G555CPK
42
42
VDD(3.3V)
DOUT
TEST
5
AUTO ADJUST
T301, HRP301 (YEL)
100 mV/DIV, 200 µs/DIV
IC701 rk (XOUT)
SERVO PROCESSOR
A/D
Approx. 100 mVp-p
4
LDD
LDS
APC
DATA
DATACK
LRSY
ASDFIN
ASDACK
ASLRCK
16MOUT
EFLG
C2F
XVSS
FSX/16MIN
XIN
XOUT
XVDD
RVDD
RCHO
RVSS
LVSS
LCHO
LVDD
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
DATA
DATACK
LRSY
ASDFIN
ASDACK
ASLRCK
16MOUT
EFLG
C2F
XVSS
FSX/16MIN
XIN
XOUT
XVDD
RVDD
RCHO
RVSS
LVSS
LCHO
LVDD
CFD-G555CP/G555CPK
– CD/MP3 Board –
– TUNER Board –
IC702 BA5826FP-E2
IC1 TA2149BN
28 GND
SP– 1
D.BUFF
GND1 1
24 FM RF-OUT
FM RF
27 SL–
SP+ 2
D.BUFF
LEVEL
SHIFT
D.BUFF
SPIN 3
RST 4
25 SLIN
AM IF
1/8
GND2 8
VCC
22 VCC
VCC
21 VCC
20 (FIN)
DRIVER
MUTE
AGC 9
AM
DET
19 OSC-OUT
18 ST-IND
17 IF-OUT
AF
FM
DET
QUAD 10
15 MPX- IN
ST/MO
FM/AM
L-OUT 12
VCO
DIVIDE
14 LPF2/MO-ST
DECODE
13 LPF1/BAND
D.BUFF
18 F–
T– 11
D.BUFF
17 F+
16 NC
15 OPIN
IC2 LC72137M-TLM-E
CE
DI
CL
DO
1
2
3
4
CCB
I/F
20 XOUT
19 XIN
REFERENCE
DIVIDER
MUTE
5
FM/AM
6
BAND
7
ST-IND
8
BAND
9
DATA SHIFT REGISTER
LATCH
LEVEL
SHIFT
IF REQ
16 DET-OUT
MUTE
19 FIN
D.BUFF
1/1 OR
1/16
SW
AF BUFF
AGC
R-OUT 11
LEVEL
SHIFT
20 AM OSC
ST
IF BUFF
FM IF
AM
OSC
23 VREF
(TIN) 10
OPOUT 14
LEVEL
DET
FM IF-IN 7
GND 8
T+ 12
GND 13
VCC2 5
AF IF-IN 6
MUTE 7
D.BUFF
21 FM OSC
BUFF BUFF
24 (SLIN)
REGULATOR
REGO 6
FM
OSC
FM
MIX
MIX OUT 4
D.BUFF
THERMAL
SHUT-DOWN
MONITOR
REG–B 5
AM
MIX
AM LOW CUT 3
26 SL+
LEVEL
SHIFT
TIN 9
23 VCC1
22 AM RF-IN
FM RF-IN 2
12BITS
PROGRAMMABLE
DIVIDER
PHASE
DETECTOR
CHARGE
PUMP
18 LP-OUT
17 LP-IN
16 PD
15 VSS
UNLOCK
DETECTOR
POWER ON
RESET
14 VDD
13 MO/ST
UNIVERSAL
COUNTER
SWALLOW
COUNTER
1/16,1/17
4BITS
1/2
12 FM IN
11 AM IN
IF IN 10
43
CFD-G555CP/G555CPK
– MAIN Board –
TNF1
TNF2
BNF2
BOUT2
BNF1
BOUT1
OUT1
OUT2
VCC
SI
SC
24
23
22
21
20
19
18
17
16
15
14
13
Surround
CAP
IC321 BD3870FS-E2
Treble1 Treble2
fc=8kHz fc=8kHz
Bass2
fo=80Hz
Bass1
fo=80Hz
Logic
Vcc/2
Vcc/2
0dB-87dB
-
7
B1
SEL1
50k
6
A2
SEL2
50k
5
A1
4
50k
50k
50k
8
9
10
11
12
GND
VIN2
50k
3
FILTER
2
C2
1
C1
Vcc/2
B2
Vcc/2
VIN1
Vcc/2
– TC Board –
IC301 TA2068N
AGC 1
LINE
NAB
AMP1 BUF AMP
A1
L.NF 3
R.IN 8
RADIO
21 REC
2.1
ALC2 ALC1
DET
REF
AMP
BUF AMP
B2
REC
AMP2
ON
7dB
ON
7dB
MIC
AMP1
MIC.NF 12
44
TAPE
RADIO
BUF AMP
A2
16 R.RAD
15 TAPE
TAPE
NAB
AMP2
MUTE
R.NF 10
MONITOR
AMP
17 LINE
ON
26dB
20 L.LO
LOGIC 19 VCC
18 R.LO
MUTE
R.RO 9
R.PO 11
22 L.RAD
BUF AMP MUTE MONITOR
AMP
B1
26dB
L.IN 5
GND 7
23 MIC I/EX
TAPE
REC
AMP1
L.RO 4
REF 6
24 L.LIN
TAPE
L.PO 2
LINE
14 R.LIN
13 MIC
CFD-G555CP/G555CPK
• IC PIN FUNCTION DESCRIPTION
CD/MP3 BOARD IC1001 LC78684E-US-E (MP3 DECODER, CD-ROM DECODER, ANTI-SHOCK CONTROLLER)
Pin No.
Pin Name
I/O
1
LRSY (I)
I
CD L/R clock input
Description
2
ADDATA (O)
O
Audio data output
3
ADBCK (O)
O
Audio bit clock output
4
ADLRCK (O)
O
Audio L/R clock output
5
C2F IN (I)
I
CD C2 error flag input
6
VSS
—
7
CKIN (I)
I
8
VSS
—
Ground
System clock (16.9344 MHz) input
Ground
9
CKOUT (O)
O
Clock (384Fs) output for external DF/DAC.
10
VSS
—
Ground
11
DVDD1
—
Digital power supply (+3.3V)
12
PW (I)
I
CD subcode data serial input (connected to +3.3V)
13
SBSY (I)
I
CD subcode block synchronized signal input (connected to +3.3V)
14
SFSY (I)
I
CD subcode frame synchronized signal input (connected to +3.3V)
15
SBCK (O)
O
Serial clock output for CD subcode transfer. (not used)
16
AVDD
—
Analog (PLL) power supply (+3.3V)
17
VPRFR
—
VCO oscillation range setting pin (connected to +3.3V)
18
VCOC
I
19
VPDO
O
VCO charge pump output
20
AVSS
—
Analog ground
21
DVDD2
—
Power supply (+1.8V)
22
VSS
—
Ground
23 to 30
MDATA0 to 7
I/O
DRAM data bus 0 to 7
31
DVDD3
—
Digital power (+3.3V)
32
VSS
—
Ground
33 to 40
MDATA8 to 15
I/O
DRAM data bus 8 to 15
41
RASB
O
Row Address Strobe signal output (L: active)
42
WEB
O
Data Write Enable signal output (L: active)
43
CASLB
O
Column Address Strobe signal output (for lower byte, L: active)
44
CASUB
O
Column Address Strobe signal output (for upper byte, L: active)
VCO control voltage input
45
OEB
O
Output enable signal output (L: active)
46 to 49
MADRS12 to 9
O
DRAM address output 12 to 9 (not used)
50
MADRS8
O
DRAM address output 8
51
DVDD4
—
Digital power supply (+3.3V)
52
VSS
—
Ground
53 to 60
MADRS7 to 0
O
DRAM address output 7 to 0
61
DVDD5
—
Power supply (+1.8V)
62
VSS
—
Ground
MP3 data request flag output (H: active)/DRAM data request flag input (H: active)
63
STREQIO (O)
I/O
64
STCKIO (O)
I/O
65
STDATIO (O)
I/O
MP3 data serial input/DRAM data serial output (not used)
66
FSYNC (O)
O
MP3 frame synchronized signal input (H: active) (not used)
67
CRCF (O)
O
68
DVDD6
—
Power supply (+3.3V)
69
VSS
—
Ground
(not used)
MP3 data transfer clock input/DRAM data transfer clock output (not used)
CDROM-CRC flag output (H: active)/DRAM data output enable signal output
(H: active) (not used)
45
CFD-G555CP/G555CPK
Pin No.
Pin Name
I/O
70
WOK (I)
I
71
CNTOK (O)
O
72
OVF (O)
O
73
CMDOUT (O)
O
Command serial data output (Nch open drain output pin)
74
CMDIN (I)
I
Command serial data input
75
CL (I)
I
Command serial clock input
76
CE (I)
I
Command enable input (H: active)
77
INTB (O)
O
Interrupt signal output (L: active)
78
RESB (I)
I
System reset input (L: active)
46
Description
DRAM write OK input (at CD-DA, H: active)/DRAM data request flag input
(not used)
Data connecting point detection completion flag output (at CD-DA, H: active)/DRAM
data serial output (at CD-ROM, H: active) (not used)
DRAM write discontinue flag output (at CD-DA, H: active)/DRAM data transfer
clock output (at CD-ROM, H: active) (not used)
79
DATAIN (I)
I
CD serial data input
80
DATACK (I)
I
CD bit clock input
CFD-G555CP/G555CPK
MAIN BOARD IC801 uPD7894216AGF-561-3BA-A (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
1
TU-CE
O
PLL IC chip enable output
Description
2
TU-DATA
O
PLL IC data output
3
TU-CLK
O
PLL IC clock output
4
TU-COUNT
I
PLL IC IF count data result input
5
TU-MUTE
O
Tuner IF request mute control output
6
SIMUKE1
I
Destination setting pin (connected to ground)
7
SIMUKE2
I
Destination setting pin (connected to ground)
8
TEST-B
I
Audio test mode input
9
VDD
—
Power supply (+3.3V)
10
TEST-A
I
CD/MP3 test mode input
11
EPROM-SCL
O
EEPROM serial clock output
12
EPROM-SDA
I/O
13
SIMUKE3
I
14
N.C
—
Not used
15
N.C
—
Not used
16
MIC_JACK
I
Detection of MIC jack signal input (G555CP:not used)
17
ISS-1
O
REC bias frequency select output (not used)
18
ISS-2
O
REC bias frequency select output (not used)
19
TU-ON
O
RADIO power control signal output
20
TAPE-ON
O
TAPE power control signal output
21
CD-ON
O
CD power control signal output
22
TEST/VPP
I
Connected to ground
23
K-LED
O
KARAOKE PON LED control signal output (G555CP:not used)
24
CTL-B
O
KARAOKE PON mode control signal output (G555CP:not used)
25
CTL-C
O
KARAOKE PON mode control signal output (G555CP:not used)
26
LED2
O
LED (illumination) control signal output
27
LED1
O
LED (illumination) control signal output
28
BUF-CTL
O
MIC control signal output (G555CP:not used)
29
LCD-RST
O
LCD driver reset output
30
LCD INH
O
LCD driver C/D signal output
EEPROM serial data input/output
Destination setting pin (connected to ground)
31
LCD CS
O
LCD driver chip select output
32
LCD DATA
O
LCD driver data output
33
LCD CLK
O
LCD driver clock output
34
N.C
—
Not used
35
FM/AM SHIFT
O
Radio shift clock signal output
36
N.C
—
Not used
37
VDD
—
Power supply pin (+3.3V)
38
X2
O
Cristal oscillator output (5MHz)
39
X1
I
Cristal oscillator input (5MHz)
40
VSS
—
Ground
41
XT2
O
Not used
42
XT1
I
Connected to ground
43
RESET
I
Reset signal input
44
AC-CHK
I
AC/DC check detect signal input
45
RMC IN
I
Remote control signal input
46
WAKE-UP
I
Wake up interrupt signal input
47
N.C
—
48
CD-DOOR
I
Not used
CD door detect signal input
47
CFD-G555CP/G555CPK
Pin No.
Pin Name
I/O
Description
49
INTB(MP3)
I
Decoder IC interrupt signal input
50
WRQ(CD)
I
CD interrupt signal input
51
AVDD
—
Power supply pin (+3.3V)
52
AVREF0
—
Power supply pin (+3.3V)
53
KEY1
I
A/D key input 1
54
KEY2
I
A/D key input 2
55
KEY3
I
A/D key input 3
56
MODEL
I
Model setting pin (connected to ground)
57
N.C
—
58
REG-CHK
I
Not used
Regulator check detect signal input
59, 60
N.C
—
Not used
61
AVSS
—
Ground
62, 63
N.C
—
Not used
64
AVREF1
—
Power supply pin (+3.3V)
65 to 67
N.C
—
Not used
68
CMDOUT(MP3)
I
COMMAND serial data input
69
CMDIN(MP3)
O
COMMAND serial data output
70
CL(MP3)
O
COMMAND serial clock output
71
N.C
—
Not used
72
DRF(CD)
I
CD focus ON detect signal input
73
DO(CD)
I
CD data input
74
DI(CD)
O
CD data output
75
CL(CD)
O
CD clock output
76
CE(CD)
O
CD chip enable output
77
FSEQ(CD)
I
CD synchro. signal detect input
78
RES(CD)
O
CD DSP IC reset output
79
RESB(MP3)
O
MP3 IC system reset output
80
CE(MP3)
O
COMMAND serial enable output
81 to 84
N.C
—
Not used
85
W-LED1
O
Woofer LED control signal output (not used)
86
W-LED2
O
Woofer LED control signal output (not used)
87 to 89
NC
—
Not used
90
P-MUTE
O
Power amp mute control signal output
91
A-MUTE
O
Audio mute control signal output
92
WOOFER ON/OFF
O
Woofer AGC control signal output
93
P-CON
O
Power control signal output
48
94
V-DATA
O
Electronic volume serial data output
95
V-CLOCK
O
Electronic volume serial clock output
96
WOOFER 1/2
O
Woofer gain control signal output
97
TAPE PLAY
I
TAPE play detect signal input
98
REC IN
I
REC signal input
99
NC
—
Not used
100
VSS
—
Ground
CFD-G555CP/G555CPK
Ver. 1.1
SECTION 7
EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
7-1.
•
•
The mechanical parts with no reference
number in the exploded views are not supplied.
Abbreviation
AUS : Australian model
CND : Canadian model
E41 : AC 230V area in E model
E92 : AC 120V area in E model
MX : Mexican model
SP
: Singapore model
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque 0
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant le
numéro spécifié.
OVERALL SECTION
3
4
cabinet (upper) section
2
4
5
4
4
4
3
SP191
4
3
3
SP393
cabinet (rear) section
SP291
1
cabinet (front) section
Ref. No.
1
2
3
4
5
Part No.
Description
3-264-875-11
3-264-873-11
3-254-143-11
3-254-145-11
2-189-049-11
LID BATTERY
HANDLE
SCREW (B3), (+) BV TAPPING
SCREW (B3), (+) BV TAPPING
COVER HANDLE
Remark
Ref. No.
SP191
SP291
SP393
Part No.
Description
Remark
1-826-352-11 SPEAKER (10CM) (L-CH)
1-826-352-11 SPEAKER (10CM) (R-CH)
1-825-767-11 SPEAKER (10CM) (WOOFER)
49
CFD-G555CP/G555CPK
7-2.
CABINET (FRONT) SECTION
61
65
62
65
63
66
59
60
58
69
63
64
68
70
67
71
65
72
64
54
not supplied
(LCD board)
65
65
57
53
71
72
56
65
55
65
52
65
51
Ref. No.
Part No.
Description
51
52
53
54
55
2-657-087-01
2-657-083-11
2-657-084-01
1-831-781-21
2-657-085-01
FRAME, X PLODE
PANEL, LCD
WINDOW, LCD
CABLE, FLEXIBLE FLAT (11 CORE)
COVER, REAR
56
57
58
59
60
2-657-082-01
2-657-088-01
2-657-090-01
3-264-886-11
A-1167-876-A
60
61
62
62
63
A-1167-984-A
3-264-885-31
A-1167-874-A
A-1167-982-A
3-254-151-01
50
Remark
Ref. No.
Part No.
Description
64
65
66
67
67
3-254-145-11
3-252-827-01
X-2108-346-1
A-1167-869-A
A-1167-977-A
SCREW (B3), (+) BV TAPPING
SCREW (B2.6), (+) BV TAPPING
CABINET (FRONT) SUB ASSY
LED 1 BOARD, COMPLETE (G555CPK)
LED 1 BOARD, COMPLETE (G555CP)
COVER, WOOFER
RING, ALIGNMENT
PLATE, LIGHT GUIDE LED
BUTTON VOLUME
VOL KEY BOARD, COMPLETE (G555CPK)
68
68
69
69
70
A-1167-870-A
A-1167-978-A
A-1167-871-A
A-1167-979-A
A-1167-872-A
LED 2 BOARD, COMPLETE (G555CPK)
LED 2 BOARD, COMPLETE (G555CP)
LED 3 BOARD, COMPLETE (G555CPK)
LED 3 BOARD, COMPLETE (G555CP)
LED 4 BOARD, COMPLETE (G555CPK)
VOL KEY BOARD, COMPLETE (G555CP)
BUTTON FUNCTION
TUNER KEY BOARD, COMPLETE (G555CPK)
TUNER KEY BOARD, COMPLETE (G555CP)
SCREW (B2.6), (+) P TAPPING
70
71
72
A-1167-980-A LED 4 BOARD, COMPLETE (G555CP)
2-664-334-01 HOLDER (L), LED
2-664-335-01 HOLDER (R), LED
Remark
CFD-G555CP/G555CPK
Ver. 1.1
7-3.
CABINET (REAR) SECTION
110
111
105
111
110
110
T901
111
F902
106
104
not supplied
(BATTERY 2 board)
101
103
108
110
102
106
109
107
103
107
Ref. No.
101
102
102
102
102
103
104
105
105
Part No.
Description
Remark
3-264-908-01 CHASSIS (TRANS)
A-1167-863-A POWER BOARD, COMPLETE
(including TRANS BOARD, COMPLETE) (MX)
A-1167-901-A POWER BOARD, COMPLETE
(including TRANS BOARD, COMPLETE) (CND)
A-1167-971-A POWER BOARD, COMPLETE
(including TRANS BOARD, COMPLETE) (E92)
A-1168-007-A POWER BOARD, COMPLETE
(including TRANS BOARD, COMPLETE) (SP, E41, AUS)
3-254-143-11
3-040-916-01
3-264-907-51
3-264-907-61
SCREW (B3), (+) BV TAPPING
FOOT (FRONT), RUBBER
CABINET REAR (MX)
CABINET REAR (CND)
Ref. No.
not supplied
(BATTERY 1 board)
Part No.
Description
105
3-264-907-71 CABINET REAR (G555CP)
106
107
108
109
110
3-238-135-01
3-252-830-01
2-067-415-01
3-266-180-02
3-254-143-01
111
0 F902
0 T901
0 T901
Remark
TERMINAL (–), BATTERY
SCREW (B3), (+) PWH TAPPING
TERMINAL (+, –), BATTERY
SHEET TRANS CHASSIS
SCREW (B3), (+) BV TAPPING
3-243-076-01 WOVEN (90), FABRIC NON
1-533-471-11 FUSE, GLASS TUBE (DIA. 5) (T4AL/250V)
1-435-964-12 TRANSFORMER, POWER
(G555CP:E92/G555CPK)
1-435-965-11 TRANSFORMER, POWER (SP, E41, AUS)
51
CFD-G555CP/G555CPK
Ver. 1.1
7-4.
CABINET (UPPER) (1) SECTION (CFD-G555CPK)
ANT1
166
167
165
164
175
S801
162
163
169
175
152
172
151
156
cabinet (upper)
(2) section
155
153
157
158
174
168
171
161
171
171
173
171
159
154
171
151
not
supplied
(JACK HOLD board)
160
151
Ref. No.
Part No.
Description
151
152
153
154
155
3-252-828-01
A-1167-880-A
2-657-080-01
A-1167-878-A
3-264-903-01
SCREW (B2.6), (+) PWH TAPPING
H/P BOARD, COMPLETE (G555CPK)
BUTTON, POWER (G555CPK)
CD KEY BOARD, COMPLETE (G555CPK)
BUTTON WOOFER
156
157
158
159
160
3-264-902-01
3-264-904-01
3-047-468-01
3-264-897-31
A-1070-124-A
SPRING CASSETTE
HOLDER BUTTON WOOFER
DAMPER
BUTTON CD
TUNER BOARD, COMPLETE (G555CPK)
161
162
163
164
3-264-916-01
2-657-081-01
3-019-395-01
1-452-732-11
TERMINAL ANTENNA
KNOB, MICVOLUM (G555CPK)
PLATE, CHUCKING
MAGNET
52
170
171
151
Remark
Ref. No.
Part No.
Description
Remark
165
3-264-889-01 SPRING CD
166
167
168
169
170
3-264-887-31
3-264-888-51
3-047-468-11
3-253-143-01
3-254-143-01
LID CD
LID CASSETTE (G555CPK)
DAMPER
SCREW (B2.6), (+) P TAPPING
SCREW (B3), (+) BV TAPPING
171
172
173
174
175
3-252-827-01
3-252-833-01
A-1167-881-A
A-1167-879-A
3-040-916-01
SCREW (B2.6), (+) BV TAPPING
SCREW (M3), (+) P
MIC BOARD, COMPLETE (G555CPK)
POWER KEY BOARD, COMPLETE (G555CPK)
FOOT (FRONT), RUBBER
ANT1
S801
1-501-918-21 ANTENNA, TELESCOPIC
1-692-960-11 SWITCH, PUSH (1KEY) (Z PUSH OPEN/CLOSE)
CFD-G555CP/G555CPK
Ver. 1.1
7-5.
CABINET (UPPER) (1) SECTION (CFD-G555CP)
215
ANT1
216
213
cabinet (upper)
(2) section
S801
214
212
218
202
not
supplied
(JACK HOLD board)
221
206
201
205
207
203
208
217
220
211
220
204
209
220
220
210
201
219
220
Ref. No.
Part No.
Description
Remark
201
202
203
204
205
3-252-828-01
A-1167-992-A
3-264-898-11
A-1167-991-A
3-264-903-01
SCREW (B2.6), (+) PWH TAPPING
H/P BOARD, COMPLETE (G555CP)
BUTTON POWER (G555CP)
CD KEY BOARD, COMPLETE (G555CP)
BUTTON WOOFER
206
207
208
209
210
3-264-902-01
3-264-904-01
3-047-468-01
3-264-897-31
A-1070-124-A
SPRING CASSETTE
HOLDER BUTTON WOOFER
DAMPER
BUTTON CD
TUNER BOARD, COMPLETE (E92)
210
211
A-1070-126-A TUNER BOARD, COMPLETE (SP, E41, AUS)
3-264-916-01 TERMINAL ANTENNA
Ref. No.
Part No.
Description
Remark
212
213
214
3-019-395-01 PLATE, CHUCKING
1-452-732-11 MAGNET
3-264-889-01 SPRING CD
215
216
217
218
219
3-264-887-31
3-264-888-41
3-047-468-11
3-253-143-01
3-254-143-01
LID CD
LID CASSETTE (G555CP)
DAMPER
SCREW (B2.6), (+) P TAPPING
SCREW (B3), (+) BV TAPPING
220
221
ANT1
S801
3-252-827-01
3-252-833-01
1-501-918-21
1-692-960-21
SCREW (B2.6), (+) BV TAPPING
SCREW (M3), (+) P
ANTENNA, TELESCOPIC
SWITCH, PUSH (1KEY) (Z PUSH OPEN/CLOSE)
53
CFD-G555CP/G555CPK
7-6.
CABINET (UPPER) (2) SECTION
269
271
not
supplied
273
270
not supplied
IC351
270
272
270
262
Q972
not supplied
Q971
260
IC371
259
265 270
269
259
264
261
tape mechanism deck
section
CD mechanism
section
274
269
258
270
257
268
266
263
251
252
253
274
254
255
Ref. No.
256
Part No.
Description
251
252
253
254
255
3-264-890-11
3-264-891-11
3-264-892-11
3-264-893-11
3-264-894-11
BUTTON PAUSE
BUTTON STOP/EJECT
BUTTON FF
BUTTON REW
BUTTON PLAY
256
257
258
259
260
3-264-895-11
3-923-736-01
3-931-379-21
3-252-828-01
1-832-026-11
BUTTON REC
COVER, CD
RUBBER, VIBRATION PROOF
SCREW (B2.6), (+) PWH TAPPING
CABLE, FLEXIBLE FLAT (16 CORE)
261
262
263
264
264
3-931-379-31
1-831-730-21
3-264-896-01
A-1167-882-A
A-1167-993-A
RUBBER, VIBRATION PROOF
CABLE, FLEXIBLE FLAT (20 CORE)
HOLDER BUTTON (MD)
MAIN BOARD, COMPLETE (G555CPK)
MAIN BOARD, COMPLETE (E92)
264
264
A-1168-010-A MAIN BOARD, COMPLETE (E41)
A-1168-035-A MAIN BOARD, COMPLETE (AUS)
54
Remark
267
Ref. No.
Part No.
Description
264
265
266
A-1169-131-A MAIN BOARD, COMPLETE (SP)
1-831-778-21 CABLE, FLEXIBLE FLAT (11 CORE)
2-657-079-01 CABINET UPPER (FRONT) (G555CPK)
266
267
268
269
270
3-264-900-51
3-264-901-31
2-108-743-01
3-254-143-01
3-252-827-01
CABINET UPPER (FRONT) (G555CP)
CABINET UPPER (BACK)
CUSHION KEY CASSETTE
SCREW (B3), (+) BV TAPPING
SCREW (B2.6), (+) BV TAPPING
271
272
273
274
IC351
3-245-709-51
A-1068-202-A
1-832-425-21
3-243-076-01
8-759-426-51
SCREW
CD/MP3 BOARD, COMPLETE
CABLE, FLEXIBLE FLAT (11 CORE)
WOVEN (90), FABRIC NON
IC BA5417
IC371
Q971
Q972
8-759-426-51 IC BA5417
8-729-037-08 TRANSISTOR KTD2058Y
8-729-037-08 TRANSISTOR KTD2058Y
Remark
CFD-G555CP/G555CPK
7-7.
TAPE MECHANISM DECK SECTION
303
304
M971
309
not
supplied
305
not
supplied
303
308
306
310
302
307
301
311
HRP301
Ref. No.
Part No.
Description
301
302
303
* 304
305
2-663-212-01
2-663-211-01
3-254-029-01
A-4547-315-A
3-237-719-02
BELT (B1), SUB
BELT (B1), MAIN
SCREW
TC BOARD, COMPLETE
CHASSIS, TC
306
307
3-237-718-01 LEVER REC
A-1159-094-A MF-G500
Remark
Ref. No.
308
309
310
Part No.
Description
Remark
3-245-709-21 SCREW
2-663-206-01 +SCREW BIND DT M2X4
2-663-207-01 +SCERW BIND M2X4.5
311
3-244-086-01 ARM, PINCH ROLLER
HRP301 3-244-085-01 HEAD, R/P
M971
2-663-205-01 PULLEY (MOTOR) (CAPSTAN/REEL)
55
CFD-G555CP/G555CPK
7-8.
OPTICAL PICK-UP SECTION (KSM-213CDP/C2NP)
506
not supplied
501
504
502
505
503
M701
M702
Ref. No.
Part No.
Description
0 501
502
503
504
505
8-848-483-05
2-174-500-01
2-626-908-01
2-627-003-01
X-2162-709-1
OPTICAL PICK-UP (KSS-213C/Q-RP)
SCREW (2X3)
SHAFT, SLED
GEAR (B) (RP)
CHASSIS ASSY (CDP), MOTOR
(including M701 (SPINDLE))
56
Remark
Ref. No.
506
M702
Part No.
Description
Remark
2-626-907-11 GEAR (A)
X-2625-769-1 GEAR ASSY (MB) (RP), MOTOR (SLED)
(including GEAR)
CFD-G555CP/G555CPK
SECTION 8
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• Accessories are given in the last of this parts
list.
• CAPACITORS
uF: µF
• COILS
uH: µH
Ref. No.
Part No.
Description
•
•
•
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
Abbreviation
AUS : Australian model
CND : Canadian model
E41 : AC 230V area in E model
E92 : AC 120V area in E model
MX : Mexican model
SP
: Singapore model
Remark
Ref. No.
Part No.
BATTERY 1
Ver. 1.1
BATTERY 2
CD KEY
CD/MP3
When indicating parts by reference number,
please include the board name.
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque 0
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant le
numéro spécifié.
Description
Remark
A-1068-202-A CD/MP3 BOARD, COMPLETE
***********************
BATTERY 1 BOARD
***************
< CAPACITOR >
3-238-135-01 TERMINAL (–), BATTERY
*************************************************************
BATTERY 2 BOARD
***************
3-238-135-01 TERMINAL (–), BATTERY
*************************************************************
A-1167-878-A CD KEY BOARD, COMPLETE (G555CPK)
A-1167-991-A CD KEY BOARD, COMPLETE (G555CP)
***********************
C701
C702
C703
C704
C705
1-164-156-11
1-104-658-91
1-164-156-11
1-126-947-11
1-162-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
100uF
0.1uF
47uF
0.001uF
20%
10%
25V
10V
25V
35V
50V
C706
C707
C708
C709
C710
1-164-156-11
1-104-658-91
1-107-826-11
1-104-658-91
1-165-176-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
100uF
0.1uF
100uF
0.047uF
20%
10%
20%
10%
25V
10V
16V
10V
16V
C711
C712
C713
C714
C715
1-107-826-11
1-162-923-11
1-162-968-11
1-164-156-11
1-126-960-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
47PF
0.0047uF
0.1uF
1uF
10%
5%
10%
C716
C717
C718
C719
C720
1-162-964-11
1-162-968-11
1-115-156-11
1-162-968-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.0047uF
1uF
0.0047uF
100PF
10%
10%
C721
C722
C723
C729
C730
1-164-156-11
1-164-156-11
1-104-658-91
1-126-927-11
1-126-923-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.1uF
0.1uF
100uF
2200uF
220uF
C731
C732
C733
C734
C737
1-162-968-11
1-162-970-11
1-162-970-11
1-162-968-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0047uF
0.01uF
0.01uF
0.0047uF
0.1uF
C740
C741
C742
C743
C744
1-164-156-11
1-115-156-11
1-164-156-11
1-165-176-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
1uF
0.1uF
0.047uF
1uF
C745
C746
C747
C748
C750
1-162-923-11
1-164-156-11
1-164-156-11
1-126-925-91
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
47PF
0.1uF
0.1uF
470uF
22PF
5%
20%
5%
50V
25V
25V
10V
50V
C751
1-162-923-11 CERAMIC CHIP
47PF
5%
50V
20%
< CONNECTOR >
KH405
1-815-551-11 CONNECTOR 3P (G555CPK)
< RESISTOR >
R401
1-216-817-11 METAL CHIP
470
5%
R402
1-216-813-11 METAL CHIP
220
5%
R403
R404
R405
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-825-11 METAL CHIP
1K
1K
2.2K
5%
5%
5%
R406
R407
R408
R409
R422
1-216-825-11
1-216-821-11
1-216-829-11
1-216-825-11
1-216-821-11
2.2K
1K
4.7K
2.2K
1K
5%
5%
5%
5%
5%
R423
R424
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1-216-817-11 METAL CHIP
1-216-813-11 METAL CHIP
470
220
5%
5%
1/10W
(G555CP)
1/10W
(G555CP)
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
(G555CP)
1/10W
1/10W
20%
16V
50V
50V
25V
50V
10%
5%
50V
50V
10V
50V
50V
20%
20%
20%
25V
25V
10V
10V
10V
10%
10%
10%
10%
50V
25V
25V
50V
25V
< SWITCH >
S401
S402
S403
S404
S405
1-786-050-21
1-786-050-21
1-786-050-21
1-786-050-21
1-786-050-21
SWITCH, KEY BOARD (POWER) (G555CP)
SWITCH, KEY BOARD (MODE) (G555CP)
SWITCH, KEY BOARD (u)
SWITCH, KEY BOARD (x)
SWITCH, KEY BOARD (WOOFER)
S406
1-786-050-21 SWITCH, KEY BOARD (PRESET +/>)
S407
1-786-050-21 SWITCH, KEY BOARD (PRESET –/.)
S417
1-786-050-21 SWITCH, KEY BOARD (FOLDER +)
S418
1-786-050-21 SWITCH, KEY BOARD (FOLDER –)
S419
1-786-050-21 SWITCH, KEY BOARD (SLEEP) (G555CP)
*************************************************************
10%
25V
10V
25V
16V
10V
57
CFD-G555CP/G555CPK
CD/MP3
Ref. No.
Part No.
Description
C753
C754
C756
C760
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
47PF
47PF
47PF
5%
5%
5%
5%
50V
50V
50V
50V
Remark
C761
C762
C763
C764
C766
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
47PF
47PF
47PF
47PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C767
C1001
C1010
C1011
C1012
1-162-919-11
1-162-923-11
1-164-156-11
1-164-156-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
47PF
0.1uF
0.1uF
1uF
5%
5%
50V
50V
25V
25V
10V
C1013
C1014
C1029
C1030
C1031
1-164-156-11
1-104-658-91
1-126-916-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
1000uF
0.1uF
0.1uF
C1037
C1042
C1043
C1044
C1054
1-164-156-11
1-104-658-91
1-164-156-11
1-164-156-11
1-126-925-91
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
100uF
0.1uF
0.1uF
470uF
C1055
C1056
C1057
C1058
C1059
1-164-156-11
1-115-156-11
1-162-923-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C1066
C1067
C1068
C1069
C1070
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C1074
C1110
1-162-919-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
Ref. No.
Part No.
Description
Remark
< TRANSISTOR >
Q701
8-729-054-57 TRANSISTOR
KTN2907AS-RTK
< RESISTOR >
20%
20%
20%
25V
10V
25V
25V
10V
0.1uF
1uF
47PF
47PF
47PF
5%
5%
5%
25V
10V
50V
50V
50V
47PF
47PF
47PF
47PF
47PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
22PF
0.01uF
5%
10%
50V
25V
20%
< CONNECTOR >
CNP701 1-779-553-21 CONNECTOR, FFC (LIF (NON-ZIF)) 16P
CNP702 1-784-742-11 CONNECTOR, FFC 20P
< FERRITE BEAD >
FB701
FB702
FB703
FB704
FB705
1-469-701-21
1-469-701-21
1-469-701-21
1-469-701-21
1-469-701-21
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FB706
FB707
FB1001
FB1002
1-469-701-21
1-469-701-21
1-469-701-21
1-469-701-21
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
FERRITE, EMI (SMD) (1608)
< IC >
IC701
IC702
IC1001
IC1002
IC1003
58
6-701-796-01
6-701-787-11
6-704-008-01
8-759-597-78
6-704-059-01
IC
IC
IC
IC
IC
25V
10V
6.3V
25V
25V
LC78646E-US-E
BA5826FP-E2
LC78684E-US-E
MSM54V16258BSL-40TSK
S-817B18AMC-CWHT2G
R701
R702
R703
R704
R705
1-216-841-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R706
R707
R708
R709
R710
1-216-841-11
1-216-797-11
1-216-833-11
1-216-837-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10
10K
22K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R711
R712
R713
R714
R715
1-216-813-11
1-216-825-11
1-216-821-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
2.2K
1K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R716
R717
R718
R719
R720
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R721
R722
R723
R724
R725
1-216-809-11
1-216-809-11
1-216-809-11
1-216-841-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
47K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R726
R727
R728
R729
R730
1-216-817-11
1-216-825-11
1-216-833-11
1-216-813-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
2.2K
10K
220
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R731
R732
R733
R734
R735
1-216-825-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R736
R737
R740
R743
R744
1-216-809-11
1-216-809-11
1-216-809-11
1-216-829-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
4.7K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R745
R753
R755
R756
R757
1-216-809-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
4.7K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R758
R759
R760
R761
R762
1-216-829-11
1-216-809-11
1-216-825-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
2.2K
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R763
R764
R765
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
1-216-841-11 METAL CHIP
220
220
47K
5%
5%
5%
1/10W
1/10W
1/10W
CFD-G555CP/G555CPK
CD/MP3
Ref. No.
Part No.
Description
Remark
R766
R1001
1-216-797-11 METAL CHIP
1-216-809-11 METAL CHIP
10
100
5%
5%
1/10W
1/10W
R1002
R1003
R1004
R1005
R1017
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1018
R1019
R1020
R1068
R1073
1-216-809-11
1-216-821-11
1-216-821-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
2.2K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1074
R1075
R1076
R1077
R1078
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1079
R1080
R1081
R1082
1-216-809-11
1-216-809-11
1-216-821-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
47
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
H/P
LCD
LED 1
Description
Remark
C437
C438
C439
1-162-923-11 CERAMIC CHIP
1-162-923-11 CERAMIC CHIP
1-162-923-11 CERAMIC CHIP
47PF
47PF
47PF
5%
5%
5%
50V
50V
50V
C440
C441
C444
1-162-923-11 CERAMIC CHIP
1-162-923-11 CERAMIC CHIP
1-126-160-11 ELECT
47PF
47PF
1uF
5%
5%
20%
50V
50V
50V
< DIODE >
D402
6-501-464-01 DIODE L-7104SRD-H (OPR/BATT)
< IC >
IC402
IC891
6-709-360-01 IC NJU6533FA2
6-701-681-01 IC RPM7140-V4
< COIL >
L401
1-410-509-11 INDUCTOR
10uH
< LIQUID CRYSTAL DISPLAY >
LCD401 1-802-087-11 DISPLAY PANEL, LIQUID CRYSTAL
< RESISTOR >
< SWITCH >
S701
1-571-936-11 SWITCH, LEAF (LIMIT)
< VIBRATOR >
X701
1-795-563-21 VIBRATOR, CERAMIC (16.9MHz)
*************************************************************
A-1167-880-A H/P BOARD, COMPLETE (G555CPK)
A-1167-992-A H/P BOARD, COMPLETE (G555CP)
*******************
< CONNECTOR >
CNP391 1-815-557-11 PIN, CONNECTOR (PWB) 9P
CNP392 1-815-552-11 PIN, CONNECTOR (PWB) 4P
* CNP393 1-815-552-21 PIN, CONNECTOR (PWB) 4P
1-216-825-11
1-216-817-11
1-216-841-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
470
47K
2.2K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R445
R448
R449
R450
R451
1-216-853-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R452
R461
R462
R463
R464
1-216-849-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R465
1-216-825-11 METAL CHIP
2.2K
5%
1/10W
R469
1-216-845-11 METAL CHIP
100K
5%
1/10W
R475
1-216-849-11 METAL CHIP
220K
5%
1/10W
*************************************************************
< JACK >
J391
R427
R428
R442
R443
R444
1-794-016-11 JACK (i)
< RESISTOR >
R192
R193
R194
R292
R293
1-216-821-11
1-216-813-11
1-216-813-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
220
1K
220
5%
5%
5%
5%
5%
A-1167-869-A LED 1 BOARD, COMPLETE (G555CPK)
A-1167-977-A LED 1 BOARD, COMPLETE (G555CP)
*********************
1/10W
1/10W
1/10W
1/10W
1/10W
R294
1-216-813-11 METAL CHIP
220
5%
1/10W
*************************************************************
< DIODE >
D403
D404
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
< RESISTOR >
LCD BOARD
**********
R471
1-216-813-11 METAL CHIP
220
5%
1/10W
R472
1-216-813-11 METAL CHIP
220
5%
1/10W
*************************************************************
2-657-086-01 HOLDER, LCD
< CAPACITOR >
C403
C406
1-126-160-11 ELECT
1-126-160-11 ELECT
1uF
1uF
20%
20%
50V
50V
59
CFD-G555CP/G555CPK
LED 2
Ref. No.
LED 3
Part No.
LED 4
MAIN
Description
Remark
A-1167-870-A LED 2 BOARD, COMPLETE (G555CPK)
A-1167-978-A LED 2 BOARD, COMPLETE (G555CP)
*********************
< DIODE >
D405
D406
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
< RESISTOR >
R473
1-216-813-11 METAL CHIP
220
5%
1/10W
R474
1-216-813-11 METAL CHIP
220
5%
1/10W
*************************************************************
A-1167-871-A LED 3 BOARD, COMPLETE (G555CPK)
A-1167-979-A LED 3 BOARD, COMPLETE (G555CP)
*********************
< DIODE >
D407
D408
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
< RESISTOR >
R476
1-216-813-11 METAL CHIP
220
5%
1/10W
R477
1-216-813-11 METAL CHIP
220
5%
1/10W
*************************************************************
A-1167-872-A LED 4 BOARD, COMPLETE (G555CPK)
A-1167-980-A LED 4 BOARD, COMPLETE (G555CP)
*********************
Ref. No.
Part No.
Description
Remark
C151
1-126-964-11 ELECT
10uF
C152
1-126-960-11 ELECT
1uF
C153
1-126-964-11 ELECT
10uF
C154
1-162-960-11 CERAMIC CHIP
220PF
C171
C172
C173
C174
C175
1-126-947-11
1-162-962-11
1-104-658-91
1-126-926-11
1-164-156-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
47uF
470PF
100uF
1000uF
0.1uF
20%
10%
20%
20%
35V
50V
10V
10V
25V
C176
C222
C223
C224
C226
1-162-970-11
1-107-826-11
1-126-961-11
1-162-964-11
1-126-961-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
0.1uF
2.2uF
0.001uF
2.2uF
10%
10%
20%
10%
20%
25V
16V
50V
50V
50V
C227
C229
C230
C231
C232
1-162-968-11
1-127-715-91
1-127-715-91
1-126-959-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0047uF
0.22uF
0.22uF
0.47uF
100PF
10%
10%
10%
20%
5%
50V
16V
16V
50V
50V
C247
C248
C251
1-126-963-11 ELECT
1-126-960-11 ELECT
1-126-964-11 ELECT
4.7uF
1uF
10uF
20%
20%
20%
C252
1-126-960-11 ELECT
1uF
C253
1-126-964-11 ELECT
10uF
C254
1-162-960-11 CERAMIC CHIP
220PF
10%
C271
C272
C273
C274
1-126-947-11
1-162-962-11
1-104-658-91
1-126-926-11
ELECT
CERAMIC CHIP
ELECT
ELECT
47uF
470PF
100uF
1000uF
20%
10%
20%
20%
C275
C276
C301
C321
C322
1-164-156-11
1-162-970-11
1-126-923-91
1-162-962-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
220uF
470PF
470PF
10%
20%
10%
10%
25V
25V
10V
50V
50V
C323
C324
C325
C326
C327
1-126-959-11
1-104-658-91
1-126-923-91
1-165-176-11
1-164-227-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.47uF
100uF
220uF
0.047uF
0.022uF
20%
20%
20%
10%
10%
50V
10V
10V
16V
25V
C328
C329
C333
C334
C336
1-107-826-11
1-107-826-11
1-162-970-11
1-164-227-11
1-126-923-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.01uF
0.022uF
220uF
10%
10%
10%
10%
20%
16V
16V
25V
25V
10V
C337
C338
C339
C340
C341
1-126-960-11
1-126-964-11
1-104-658-91
1-104-658-91
1-104-662-91
ELECT
ELECT
ELECT
ELECT
ELECT
1uF
10uF
100uF
100uF
22uF
20%
20%
20%
20%
20%
50V
50V
10V
10V
25V
C342
C343
1-162-927-11 CERAMIC CHIP
1-126-964-11 ELECT
100PF
10uF
5%
20%
50V
50V
< DIODE >
D409
D410
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
6-501-464-01 DIODE L-7104SRD-H (ILLUMINATION)
< RESISTOR >
R478
1-216-813-11 METAL CHIP
220
5%
1/10W
R479
1-216-813-11 METAL CHIP
220
5%
1/10W
*************************************************************
A-1167-882-A
A-1167-993-A
A-1168-010-A
A-1168-035-A
A-1169-131-A
MAIN BOARD, COMPLETE (G555CPK)
MAIN BOARD, COMPLETE (E92)
MAIN BOARD, COMPLETE (E41)
MAIN BOARD, COMPLETE (AUS)
MAIN BOARD, COMPLETE (SP)
*********************
3-252-827-01 SCREW (B2.6), (+) BV TAPPING
20%
50V
(G555CPK)
20%
50V
(G555CPK)
20%
50V
(G555CPK)
10%
50V
(G555CPK)
50V
50V
50V
(G555CPK)
20%
50V
(G555CPK)
20%
50V
(G555CPK)
50V
(G555CPK)
35V
50V
10V
10V
< CAPACITOR >
C122
C123
C124
C126
C127
1-107-826-11
1-126-961-11
1-162-964-11
1-126-961-11
1-162-968-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
2.2uF
0.001uF
2.2uF
0.0047uF
10%
20%
10%
20%
10%
16V
50V
50V
50V
50V
C129
C130
C131
C132
C147
1-127-715-91
1-127-715-91
1-126-959-11
1-162-927-11
1-126-963-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.22uF
0.22uF
0.47uF
100PF
4.7uF
10%
10%
20%
5%
20%
16V
16V
50V
50V
50V
C148
1-126-960-11 ELECT
1uF
20%
50V
60
CFD-G555CP/G555CPK
MAIN
Ref. No.
Part No.
Description
Remark
C346
C348
C349
1-126-942-61 ELECT
1-128-548-11 ELECT
1-104-666-11 ELECT
1000uF
4700uF
220uF
20%
20%
20%
25V
25V
25V
C350
C351
C352
C353
C354
1-162-995-11
1-104-658-91
1-107-826-11
1-104-658-91
1-104-658-91
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0.022uF
100uF
0.1uF
100uF
100uF
20%
10%
20%
20%
50V
10V
16V
10V
10V
C355
C356
C357
C358
C359
1-104-658-91
1-104-658-91
1-164-156-11
1-164-156-11
1-104-662-91
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
100uF
0.1uF
0.1uF
22uF
20%
20%
20%
10V
10V
25V
25V
25V
C360
C361
C366
C371
C381
1-126-961-11
1-162-970-11
1-162-927-11
1-104-658-91
1-126-923-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
2.2uF
0.01uF
100PF
100uF
220uF
20%
10%
5%
20%
20%
50V
25V
50V
10V
10V
C415
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C416
1-104-658-91 ELECT
100uF
20%
C417
1-126-963-11 ELECT
4.7uF
20%
C418
1-126-963-11 ELECT
4.7uF
20%
C419
1-104-658-91 ELECT
100uF
20%
C420
1-126-947-11 ELECT
47uF
20%
C421
1-126-960-11 ELECT
1uF
20%
C422
1-126-947-11 ELECT
47uF
20%
C423
1-104-662-91 ELECT
22uF
20%
C424
1-126-964-11 ELECT
10uF
20%
C425
1-127-715-91 CERAMIC CHIP
0.22uF
C426
1-127-715-91 CERAMIC CHIP
0.22uF
C431
1-162-927-11 CERAMIC CHIP
100PF
C432
1-162-927-11 CERAMIC CHIP
100PF
C433
1-162-927-11 CERAMIC CHIP
100PF
C434
1-162-964-11 CERAMIC CHIP
0.001uF
C435
1-162-927-11 CERAMIC CHIP
100PF
C436
C801
C802
1-164-156-11 CERAMIC CHIP
1-126-947-11 ELECT
1-162-927-11 CERAMIC CHIP
0.1uF
47uF
100PF
C803
C804
C805
C817
C820
1-162-964-11
1-162-970-11
1-126-964-11
1-164-156-11
1-162-915-11
0.001uF
0.01uF
10uF
0.1uF
10PF
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
25V
(G555CPK)
10V
(G555CPK)
50V
(G555CPK)
50V
(G555CPK)
10V
(G555CPK)
35V
(G555CPK)
50V
(G555CPK)
35V
(G555CPK)
25V
(G555CPK)
50V
(G555CPK)
10%
16V
(G555CPK)
10%
16V
(G555CPK)
5%
50V
(G555CPK)
5%
50V
(G555CPK)
5%
50V
(G555CPK)
10%
50V
(G555CPK)
5%
50V
(G555CPK)
25V
20%
35V
5%
50V
10%
10%
20%
0.5PF
50V
25V
50V
25V
50V
Ref. No.
Part No.
Description
C821
C823
C824
C825
C826
1-162-915-11
1-104-658-91
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
100uF
100PF
100PF
100PF
0.5PF
20%
5%
5%
5%
Remark
50V
10V
50V
50V
50V
C827
C828
C829
C830
C832
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C833
C834
C835
C836
C837
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C838
C839
C840
C841
C842
1-162-927-11
1-162-964-11
1-162-927-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.001uF
100PF
0.001uF
0.001uF
5%
10%
5%
10%
10%
50V
50V
50V
50V
50V
C843
C844
C845
C846
C850
1-162-970-11
1-162-927-11
1-162-927-11
1-164-156-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
100PF
100PF
0.1uF
100PF
10%
5%
5%
5%
25V
50V
50V
25V
50V
C851
C852
C853
C854
C855
1-162-927-11
1-162-927-11
1-162-970-11
1-104-658-91
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100PF
100PF
0.01uF
100uF
10uF
5%
5%
10%
20%
20%
50V
50V
25V
10V
50V
C856
C857
C858
C859
C860
1-107-826-11
1-162-927-11
1-162-919-11
1-162-919-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
22PF
22PF
22PF
10%
5%
5%
5%
5%
16V
50V
50V
50V
50V
C861
C862
C863
C864
C869
1-162-919-11
1-162-970-11
1-162-970-11
1-115-156-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
0.01uF
0.01uF
1uF
0.1uF
5%
10%
10%
10%
50V
25V
25V
10V
16V
C951
C953
C954
C955
C957
1-164-227-11
1-164-227-11
1-126-923-91
1-164-227-11
1-126-923-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.022uF
0.022uF
220uF
0.022uF
220uF
10%
10%
20%
10%
20%
25V
25V
10V
25V
10V
C958
C959
C960
C961
C972
1-164-227-11
1-164-227-11
1-126-923-91
1-126-923-91
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.022uF
0.022uF
220uF
220uF
0.1uF
10%
10%
20%
20%
25V
25V
10V
10V
25V
< CONNECTOR >
* CNP301
CNP303
CNP801
CNP802
CNP804
1-815-553-11
1-815-554-11
1-770-519-31
1-691-052-31
1-815-444-11
PIN, CONNECTOR (PWB) 5P
PIN, CONNECTOR (PWB) 6P
CONNECTOR, FFC/FPC 11P
HOUSING, CONNECTOR 20P
PIN, CONNECTOR (PWB) 3P (G555CP)
CNP804 1-815-445-11 PIN, CONNECTOR (PWB) 4P (G555CPK)
61
CFD-G555CP/G555CPK
MAIN
Ref. No.
Part No.
Description
Remark
CNP806 1-815-443-11 PIN, CONNECTOR (PWB) 2P
< DIODE >
Ref. No.
Part No.
Description
Remark
Q323
8-729-027-46 TRANSISTOR
DTC114YKA-T146
Q351
Q352
Q354
Q401
Q402
8-729-036-89
8-729-028-90
8-729-036-86
8-729-120-28
8-729-120-28
KTC3198GR-AT
DTA143ZUA-T106
KTC3203Y-AT
2SC1623-L5L6 (G555CPK)
2SC1623-L5L6 (G555CPK)
Q403
8-729-028-99 TRANSISTOR
DTC114YUA-T106
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
D320
D321
D322
D323
D325
6-500-335-01
8-719-988-61
8-719-988-61
8-719-988-61
6-500-335-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2838-T112-1
1SS355TE-17
1SS355TE-17
1SS355TE-17
MC2838-T112-1
D351
D801
D803
D805
D806
6-500-848-01
8-719-082-07
8-719-069-54
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
MC2840-T112-1
KDS121-RTK
UDZSTE-175.1B
1SS355TE-17
1SS355TE-17
Q404
8-729-028-76 TRANSISTOR
DTA114YUA-T106
Q405
Q802
Q803
8-729-120-28 TRANSISTOR
8-729-027-26 TRANSISTOR
8-729-027-46 TRANSISTOR
(G555CPK)
2SC1623-L5L6 (G555CPK)
DTA114YKA-T146
DTC114YKA-T146
D951
D952
D954
D955
D956
8-719-000-07
8-719-000-07
8-719-977-28
8-719-978-33
8-719-083-58
DIODE
DIODE
DIODE
DIODE
DIODE
MC2836
MC2836
DTZ10B
DTZ-TT11-6.8B
UDZSTE-173.9B
Q806
Q808
Q811
Q812
Q813
8-729-922-10
8-729-027-46
8-729-027-46
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1577-QR
DTC114YKA-T146
DTC114YKA-T146
2SC1623-L5L6
2SC1623-L5L6
Q814
Q815
Q816
Q817
Q951
8-729-028-92
8-729-027-26
8-729-037-03
8-729-922-10
8-729-029-04
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA144TUA-T106
DTA114YKA-T146
KTA1266GR-AT
2SA1577-QR (G555CPK)
DTC123JUA-T106
Q952
Q953
Q954
Q956
8-729-037-03
8-729-029-09
8-729-036-89
8-729-036-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KTA1266GR-AT
DTC143EUA-T106
KTC3198GR-AT
KTC3203Y-AT
(G555CPK)
< FERRITE BEAD >
FB801
1-469-701-21 FERRITE, EMI (SMD) (1608)
< IC >
IC321
IC401
IC801
IC802
IC803
6-701-824-11
8-759-332-64
6-806-432-01
6-700-336-01
6-703-285-01
IC
IC
IC
IC
IC
BD3870FS-E2
BA3837 (G555CPK)
uPD7894216AGF-561-3BA-A
CAT24WC02WI-1.8-TE13
S-812C33AUA-C2NT2G
IC804
6-705-413-01 IC BD4826G-TR
< RESISTOR >
< JUMPER RESISTOR >
JC302
1-216-841-11 METAL CHIP
47K
5%
JC303
1-216-841-11 METAL CHIP
47K
5%
JC304
JC305
1-216-864-11 SHORT CHIP
1-216-841-11 METAL CHIP
JC306
1-216-864-11 SHORT CHIP
0 (EXCEPT AUS)
47K
5%
1/10W
(SP, E41, AUS)
0 (G555CP:E92/G555CPK)
JC309
JC310
JC391
JC401
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
0 (EXCEPT SP)
0 (G555CPK)
0
0 (G555CPK)
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
< COIL >
L802
L803
L804
L805
L806
1-410-509-11
1-410-509-11
1-410-509-11
1-410-509-11
1-410-521-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
10uH
10uH
10uH
100uH
L807
L809
1-410-521-11 INDUCTOR
1-414-142-61 INDUCTOR
100uH
1uH
< TRANSISTOR >
Q171
Q271
Q321
Q322
62
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
1/10W
(SP)
1/10W
(AUS)
R123
R124
R125
R127
R128
1-216-829-11
1-216-825-11
1-216-829-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
2.2K
4.7K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R134
R151
1-216-853-11 METAL CHIP
1-216-833-11 METAL CHIP
470K
10K
5%
5%
R152
1-216-829-11 METAL CHIP
4.7K
5%
R153
1-216-829-11 METAL CHIP
4.7K
5%
R154
1-216-833-11 METAL CHIP
10K
5%
1/10W
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
R172
R173
R175
R176
R178
1-216-833-11
1-216-825-11
1-216-813-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
220
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R181
R223
R224
R225
R227
1-216-793-11
1-216-829-11
1-216-825-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7
4.7K
2.2K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R228
R234
R251
1-216-825-11 METAL CHIP
1-216-853-11 METAL CHIP
1-216-833-11 METAL CHIP
2.2K
470K
10K
5%
5%
5%
R252
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
1/10W
1/10W
(G555CPK)
1/10W
(G555CPK)
CFD-G555CP/G555CPK
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R433
1-216-841-11 METAL CHIP
47K
5%
R434
1-216-821-11 METAL CHIP
1K
5%
R435
1-216-829-11 METAL CHIP
4.7K
5%
R436
1-216-825-11 METAL CHIP
2.2K
5%
R437
1-216-821-11 METAL CHIP
1K
5%
R438
1-216-821-11 METAL CHIP
1K
5%
R439
1-216-817-11 METAL CHIP
470
5%
R440
1-216-817-11 METAL CHIP
470
5%
R441
1-216-849-11 METAL CHIP
220K
5%
R446
1-216-817-11 METAL CHIP
470
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R453
1-216-817-11 METAL CHIP
470
5%
R454
1-216-841-11 METAL CHIP
47K
5%
R455
1-216-841-11 METAL CHIP
47K
5%
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R459
R460
1-216-809-11 METAL CHIP
1-216-841-11 METAL CHIP
100
47K
5%
5%
1K
2.2K
2.2K
4.7K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R801
R802
R803
R804
R805
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
1K
4.7K
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R806
R807
R808
R809
R810
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-817-11
1-216-797-11
1-216-797-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
10
10
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R811
R814
R815
R816
R817
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(G555CPK)
R363
R364
R365
R366
R371
1-216-813-11
1-216-857-11
1-216-857-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
1M
1M
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R818
R819
R820
R821
R822
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R372
R429
1-216-833-11 METAL CHIP
1-216-825-11 METAL CHIP
10K
2.2K
5%
5%
R430
1-216-841-11 METAL CHIP
47K
5%
R823
R824
R825
R826
R827
1-216-821-11
1-216-821-11
1-216-833-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
470
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R431
1-216-817-11 METAL CHIP
470
5%
R432
1-216-821-11 METAL CHIP
1K
5%
1/10W
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
R828
R829
R830
R831
R832
1-216-829-11
1-216-829-11
1-216-809-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
100
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R253
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
(G555CPK)
R254
1-216-833-11 METAL CHIP
10K
5%
R272
R273
R275
R276
1-216-833-11
1-216-825-11
1-216-813-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
220
100
5%
5%
5%
5%
1/10W
(G555CPK)
1/10W
1/10W
1/10W
1/10W
R278
R281
R307
R322
R323
1-216-821-11
1-216-793-11
1-216-864-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
1K
4.7
0
1K
1K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R325
R326
R328
R329
R330
1-216-825-11
1-216-821-11
1-216-821-11
1-216-825-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
1K
1K
2.2K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R331
R332
R333
R334
R335
1-216-837-11
1-216-853-11
1-216-833-11
1-216-817-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
470K
10K
470
22K
5%
5%
5%
5%
5%
R336
R337
R338
R339
R340
1-216-833-11
1-216-837-11
1-216-825-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
2.2K
1K
1K
R341
R342
R343
R344
R346
1-216-821-11
1-216-825-11
1-216-825-11
1-216-829-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R347
R348
R351
R353
R356
1-216-817-11
1-216-821-11
1-216-829-11
1-216-829-11
1-216-821-11
R357
R359
R360
R361
R362
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
1/10W
(G555CPK)
63
CFD-G555CP/G555CPK
MAIN
Ref. No.
MIC
Part No.
Description
R833
R834
R835
R836
R837
1-216-841-11
1-216-821-11
1-216-817-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
470
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R838
R839
R840
R841
R842
1-216-829-11
1-216-841-11
1-216-829-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
4.7K
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(G555CPK)
R843
1-216-821-11 METAL CHIP
1K
5%
R845
R846
R847
R848
1-216-821-11
1-216-833-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
4.7K
4.7K
5%
5%
5%
5%
1/10W
(G555CPK)
1/10W
1/10W
1/10W
1/10W
R849
R850
R851
R852
R853
1-216-829-11
1-216-833-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R854
R855
R856
R857
R858
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R859
R860
R861
R862
R863
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R864
R865
R866
R867
1-216-821-11
1-216-845-11
1-216-797-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
10
22K
5%
5%
5%
5%
R868
1-216-821-11 METAL CHIP
1K
5%
1/10W
1/10W
1/10W
1/10W
(G555CPK)
1/10W
R869
R870
R871
R872
R873
1-216-821-11
1-216-821-11
1-216-817-11
1-216-809-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
470
100
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R874
R875
R876
R877
R878
1-216-829-11
1-216-829-11
1-216-829-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R879
R880
R881
R882
R883
1-216-845-11
1-216-849-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
220K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R884
R885
R886
R887
R888
1-216-813-11
1-216-813-11
1-216-813-11
1-216-841-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
47K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
R889
R890
R891
R892
1-216-841-11
1-216-841-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R893
Remark
47K
47K
10K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
(G555CP)
1/10W
(G555CPK)
1-216-821-11 METAL CHIP
1K
5%
R894
R895
1-216-833-11 METAL CHIP
1-216-821-11 METAL CHIP
10K
1K
5%
5%
R896
1-216-821-11 METAL CHIP
1K
5%
R897
R898
1-216-797-11 METAL CHIP
1-216-809-11 METAL CHIP
10
100
5%
5%
1/10W
1/10W
(G555CPK)
1/10W
(G555CPK)
1/10W
1/10W
R899
R941
R942
R943
R944
1-216-809-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R945
R946
R947
R948
R949
1-216-825-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R950
R951
R952
R953
R955
1-216-825-11
1-216-845-11
1-216-825-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
2.2K
2.2K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R957
R958
R960
R961
R964
1-216-809-11
1-216-821-11
1-216-809-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
100
1K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R965
1-216-817-11 METAL CHIP
470
5%
1/10W
< VIBRATOR >
X801
1-795-526-12 VIBRATOR, CERAMIC (5MHz)
*************************************************************
A-1167-881-A MIC BOARD, COMPLETE (G555CPK)
********************
< CAPACITOR >
C402
C408
C414
1-126-960-11 ELECT
1-165-176-11 CERAMIC CHIP
1-162-968-11 CERAMIC CHIP
1uF
20%
0.047uF 10%
0.0047uF 10%
< CONNECTOR >
CNP394 1-815-444-11 PIN, CONNECTOR (PWB) 3P
< JACK >
J401
64
1-766-190-11 JACK (MIC MIX)
< COIL >
L302
L303
L304
1-410-509-11 INDUCTOR
1-410-509-11 INDUCTOR
1-410-509-11 INDUCTOR
10uH
10uH
10uH
50V
16V
50V
CFD-G555CP/G555CPK
MIC
Ref. No.
Part No.
Description
Remark
Ref. No.
< RESISTOR >
R426
1-216-821-11 METAL CHIP
1K
5%
Part No.
POWER KEY
Ver. 1.1
TRANS TC
Description
Remark
A-1167-863-A TRANS BOARD, COMPLETE
(including POWER BOARD, COMPLETE) (MX)
A-1167-901-A TRANS BOARD, COMPLETE
(including POWER BOARD, COMPLETE) (CND)
A-1167-971-A TRANS BOARD, COMPLETE
(including POWER BOARD, COMPLETE) (E92)
A-1168-007-A TRANS BOARD, COMPLETE
(including POWER BOARD, COMPLETE) (SP, E41, AUS)
********************
1/10W
< VARIABLE RESISTOR >
RV401 1-227-629-11 RES, VAR, CARBON
10K (MIC LEVEL)
*************************************************************
A-1167-863-A POWER BOARD, COMPLETE
(including TRANS BOARD,COMPLETE) (MX)
A-1167-901-A POWER BOARD, COMPLETE
(including TRANS BOARD, COMPLETE) (CND)
A-1167-971-A POWER BOARD, COMPLETE
(including TRANS BOARD,COMPLETE) (E92)
A-1168-007-A POWER BOARD, COMPLETE
(including TRANS BOARD,COMPLETE) (SP, E41, AUS)
***********************
POWER
1-533-233-31 FUSE HOLDER
3-254-143-01 SCREW (B3), (+) BV TAPPING
3-264-908-01 CHASSIS (TRANS)
************************************************************
A-4547-315-A TC BOARD, COMPLETE
******************
*
< CAPACITOR >
< CAPACITOR >
C901
C902
C903
C904
C909
1-162-995-11
1-162-995-11
1-162-995-11
1-162-995-11
1-126-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.022uF
0.022uF
0.022uF
0.022uF
2200uF
20%
50V
50V
50V
50V
25V
< JACK >
0 CNJ901 1-526-818-11 INLET, AC (- AC IN)
(G555CP:E92/G555CPK:MX)
0 CNJ901 1-526-838-11 INLET, AC 2P (- AC IN) (SP, E41, AUS)
0 CNJ901 1-540-009-11 INLET, AC (- AC IN) (CND)
< CONNECTOR >
CNP902 1-815-552-11 PIN, CONNECTOR (PWB) 4P
< DIODE >
D901
8-719-046-47 DIODE 1N5401TM
D902
8-719-046-47 DIODE 1N5401TM
D903
8-719-046-47 DIODE 1N5401TM
D904
8-719-046-47 DIODE 1N5401TM
*************************************************************
C101
C102
C103
C104
C105
1-162-964-11
1-104-658-91
1-165-176-11
1-162-966-11
1-162-923-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
100uF
0.047uF
0.0022uF
47PF
10%
20%
10%
10%
5%
50V
10V
16V
50V
50V
C107
C201
C202
C203
C204
1-162-962-11
1-162-964-11
1-104-658-91
1-165-176-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
470PF
0.001uF
100uF
0.047uF
0.0022uF
10%
10%
20%
10%
10%
50V
50V
10V
16V
50V
C205
C207
C301
C302
C303
1-162-923-11
1-162-962-11
1-104-658-91
1-104-658-91
1-104-658-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
47PF
470PF
100uF
100uF
100uF
5%
10%
20%
20%
20%
50V
50V
10V
10V
10V
C304
C305
C306
C307
1-126-947-11
1-162-962-11
1-162-970-11
1-162-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
470PF
0.01uF
0.001uF
20%
10%
10%
10%
35V
50V
25V
50V
< CONNECTOR >
CN303
1-568-830-11 CONNECTOR, FFC 11P
A-1167-879-A POWER KEY BOARD, COMPLETE (G555CPK)
**************************
IC301
< DIODE >
D401
< IC >
8-759-264-71 IC TA2068N
< JUMPER RESISTOR >
8-719-059-97 DIODE L-34HD (KARAOKEPON)
< RESISTOR >
R401
R402
R421
R422
R456
1-216-817-11
1-216-813-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R457
R458
1-216-829-11 METAL CHIP
1-216-813-11 METAL CHIP
470
220
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
4.7K
220
5%
5%
1/10W
1/10W
JC301
JC302
JC303
JC304
JC305
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC306
JC307
JC308
1-216-295-91 SHORT CHIP
1-216-864-11 SHORT CHIP
1-216-295-91 SHORT CHIP
0
0
0
< TRANSISTOR >
< SWITCH >
Q301
S401
1-786-050-21 SWITCH, KEY BOARD (POWER)
S402
1-786-050-21 SWITCH, KEY BOARD (MODE)
S419
1-786-050-21 SWITCH, KEY BOARD (KARAOKEPON)
************************************************************
8-729-901-81 TRANSISTOR
2SC2412K-T-146-R
< RESISTOR >
R101
R102
1-216-835-11 METAL CHIP
1-216-807-11 METAL CHIP
15K
68
5%
5%
1/10W
1/10W
65
CFD-G555CP/G555CPK
Ver. 1.1
TC TUNER
Ref. No.
Remark
Ref. No.
R103
R104
R105
1-216-843-11 METAL CHIP
1-216-835-11 METAL CHIP
1-216-835-11 METAL CHIP
Part No.
Description
68K
15K
15K
5%
5%
5%
1/10W
1/10W
1/10W
C15
1-162-970-11 CERAMIC CHIP
C15
1-164-227-11 CERAMIC CHIP
R106
R110
R111
R112
R201
1-216-825-11
1-216-809-11
1-216-829-11
1-216-827-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100
4.7K
3.3K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C18
C20
1-126-923-91 ELECT
1-107-826-11 CERAMIC CHIP
10%
25V
(SP, E41, AUS)
0.022uF 10%
25V
(G555CP:E92/G555CPK)
220uF
20%
10V
0.1uF
10%
16V
R202
R203
R204
R205
R206
1-216-807-11
1-216-843-11
1-216-835-11
1-216-835-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68
68K
15K
15K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C21
C22
C23
C24
C26
1-126-960-11
1-107-826-11
1-126-960-11
1-162-960-11
1-162-927-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
1uF
220PF
100PF
20%
10%
20%
10%
5%
50V
16V
50V
50V
50V
R210
R211
R212
R301
R302
1-216-025-11
1-216-829-11
1-216-827-11
1-216-857-11
1-216-829-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
3.3K
1M
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C27
C29
C30
C31
C32
1-162-927-11
1-104-658-91
1-162-970-11
1-162-919-11
1-162-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100uF
0.01uF
22PF
0.001uF
5%
20%
10%
5%
10%
50V
10V
25V
50V
50V
R303
R304
R305
R306
R307
1-216-829-11
1-216-821-11
1-216-817-11
1-218-867-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
470
6.8K
10
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C33
C34
C35
C37
C39
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
16V
R308
R309
R314
R315
1-216-837-11
1-216-805-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47
470
470
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
C41
C42
C43
C47
C49
1-164-230-11
1-162-927-11
1-162-919-11
1-162-915-11
1-161-051-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
220PF
100PF
22PF
10PF
0.01uF
5%
5%
5%
0.5PF
10%
50V
50V
50V
50V
25V
C51
C52
C53
C54
C55
1-162-919-11
1-162-915-11
1-137-190-91
1-126-923-91
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
FILM
ELECT
CERAMIC CHIP
22PF
10PF
0.22uF
220uF
100PF
5%
0.5PF
5%
20%
5%
50V
50V
50V
10V
50V
C56
C57
C59
C60
C61
1-162-964-11
1-162-964-11
1-162-927-11
1-162-964-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
100PF
0.001uF
100PF
10%
10%
5%
10%
5%
50V
50V
50V
50V
50V
C62
C63
C65
C66
C68
1-162-927-11
1-162-927-11
1-126-963-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
4.7uF
100PF
100PF
5%
5%
20%
5%
5%
50V
50V
50V
50V
50V
C77
1-162-968-11 CERAMIC CHIP
C78
1-162-968-11 CERAMIC CHIP
C80
C95
1-162-970-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
< SWITCH >
S301
1-786-126-11 SWITCH, SLIDE (REC/PB)
< TRANSFORMER >
T301
1-416-041-11 TRANSFORMER, BIAS OSCILLATION
*************************************************************
A-1070-124-A TUNER BOARD, COMPLETE
(G555CP:E92/G555CPK)
A-1070-126-A TUNER BOARD, COMPLETE (SP, E41, AUS)
**********************
3-264-916-01 TERMINAL ANTENNA
< CAPACITOR >
C1
C4
C7
C8
C9
1-162-923-11
1-162-964-11
1-162-910-11
1-162-964-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
0.001uF
5PF
0.001uF
10PF
5%
10%
0.25PF
10%
0.5PF
50V
50V
50V
50V
50V
C10
C11
C12
C13
1-126-960-11
1-107-826-11
1-126-963-11
1-162-970-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
C14
1-162-970-11 CERAMIC CHIP
1uF
20%
50V
0.1uF
10%
16V
4.7uF
20%
50V
0.01uF
10%
25V
(G555CP:E92/G555CPK)
0.01uF
10%
25V
(SP, E41, AUS)
Part No.
Description
Remark
0.01uF
0.0047uF 10%
50V
(SP, E41, AUS)
0.0047uF 10%
50V
(SP, E41, AUS)
0.01uF
10%
25V
0.001uF 10%
50V
< FILTER >
C14
1-164-227-11 CERAMIC CHIP
CF2
CF4
< CONNECTOR >
CNP1
1-568-854-11 CONNECTOR, FFC 11P
< TRIMMER >
0.022uF 10%
25V
(G555CP:E92/G555CPK)
CT1
CT3
66
1-760-235-81 FILTER, CERAMIC
1-781-962-21 FILTER, CERAMIC
1-141-442-91 CAP, CERAMIC TRIMMER
1-141-304-21 CAP, CERAMIC TRIMMER
20PF
10PF
CFD-G555CP/G555CPK
TUNER
Ref. No.
Part No.
Description
Remark
< DIODE >
D1
D2
D3
D10
D11
8-719-078-48
8-719-078-48
8-719-050-69
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
KV1471ETR-G
KV1471ETR-G
KV1520N
1SS355TE-17
1SS355TE-17
Ref. No.
Part No.
TUNER KEY
VOL KEY
Description
Remark
R57
R58
1-216-809-11 METAL CHIP
1-216-825-11 METAL CHIP
100
2.2K
5%
5%
1/10W
1/10W
R59
R60
R61
R63
R65
1-216-825-11
1-216-825-11
1-216-825-11
1-216-833-11
1-216-833-11
2.2K
2.2K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R91
R92
R94
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
1-216-821-11 METAL CHIP
220
220
1K
5%
5%
5%
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
< IC >
IC1
IC2
6-700-512-01 IC TA2149BN
8-759-483-40 IC LC72137M-TLM-E
< TRANSFORMER >
< JUMPER RESISTOR >
T1
T2
JC1
JC2
JC3
JC4
JC5
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC6
JC11
JC12
JC13
JC24
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0 (SP, E41, AUS)
JC33
JC34
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
< VIBRATOR >
X1
1-795-449-11 VIBRATOR, CRYSTAL (75kHz)
*************************************************************
A-1167-874-A TUNER KEY BOARD, COMPLETE (G555CPK)
A-1167-982-A TUNER KEY BOARD, COMPLETE (G555CP)
**************************
< RESISTOR >
0
0
< COIL >
L1
L2
L3
L4
L11
1-409-775-11
1-416-509-11
1-754-117-12
1-411-234-21
1-414-142-11
L21
1-410-509-11 INDUCTOR
1-433-741-11 TRANSFORMER, IF
1-419-465-11 COIL (DET)
COIL, AIR-CORE
COIL, AIR-CORE
ANTENNA, FERRITE-ROD (MW)
COIL, AM OSC
INDUCTOR
1uH (G555CP:E92/G555CPK)
R411
R412
R413
R414
R415
1-216-817-11
1-216-813-11
1-216-821-11
1-216-821-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
220
1K
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S409
10uH
< RESISTOR >
R1
R2
R3
R4
R5
1-216-817-11
1-216-817-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
10K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R10
R11
R13
R14
R24
1-216-805-11
1-216-825-11
1-216-821-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
2.2K
1K
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R30
R31
R32
R33
R40
1-216-837-11
1-216-829-11
1-216-845-11
1-216-833-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
4.7K
100K
10K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R41
R50
R51
R52
R53
1-216-833-11
1-216-821-11
1-216-833-11
1-216-864-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
1K
10K
0
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R54
R55
R56
1-216-817-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-813-11 METAL CHIP
470
10K
220
5%
5%
5%
1/10W
1/10W
1/10W
1-786-050-21 SWITCH, KEY BOARD
(DISPLAY/ENTER/MEMORY)
S410
1-786-050-21 SWITCH, KEY BOARD (TUNER +)
S411
1-786-050-21 SWITCH, KEY BOARD (TUNER –)
S412
1-786-050-21 SWITCH, KEY BOARD (RADIO BAND)
S413
1-786-050-21 SWITCH, KEY BOARD (REPEAT)
*************************************************************
A-1167-876-A VOL KEY BOARD, COMPLETE (G555CPK)
A-1167-984-A VOL KEY BOARD, COMPLETE (G555CP)
***********************
< CAPACITOR >
C404
1-162-970-11 CERAMIC CHIP
0.01uF
10%
25V
2.2K
1K
4.7K
2.2K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< RESISTOR >
R416
R417
R418
R419
R420
1-216-825-11
1-216-821-11
1-216-829-11
1-216-825-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
< SWITCH >
S414
1-786-050-21 SWITCH, KEY BOARD (VOL –)
S415
1-786-050-21 SWITCH, KEY BOARD (VOL +)
S416
1-786-050-21 SWITCH, KEY BOARD (SOUND)
*************************************************************
67
CFD-G555CP/G555CPK
Ver. 1.1
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
**************
54
164
213
260
262
1-831-781-21
1-452-732-11
1-452-732-11
1-832-026-11
1-831-730-21
CABLE, FLEXIBLE FLAT (11 CORE)
MAGNET
MAGNET
CABLE, FLEXIBLE FLAT (16 CORE)
CABLE, FLEXIBLE FLAT (20 CORE)
265
273
307
0 501
505
1-831-778-21
1-832-425-21
A-1159-094-A
8-848-483-05
X-2162-709-1
CABLE, FLEXIBLE FLAT (11 CORE)
CABLE, FLEXIBLE FLAT (11 CORE)
MF-G500
OPTICAL PICK-UP (KSS-213C/Q-RP)
CHASSIS ASSY (CDP), MOTOR
(including M701 (SPINDLE))
ANT1
0 F902
HRP301
IC351
IC371
1-501-918-21
1-533-471-11
3-244-085-01
8-759-426-51
8-759-426-51
ANTENNA, TELESCOPIC
FUSE, GLASS TUBE (DIA. 5) (T4AL/250V)
HEAD, R/P
IC BA5417
IC BA5417
M702
M971
Q971
Q972
S801
SP191
SP291
SP393
0 T901
X-2625-769-1 GEAR ASSY (MB) (RP), MOTOR (SLED)
(including GEAR)
2-663-205-01 PULLEY (MOTOR) (CAPSTAN/REEL)
8-729-037-08 TRANSISTOR KTD2058Y
8-729-037-08 TRANSISTOR KTD2058Y
1-692-960-11 SWITCH, PUSH (1KEY) (Z PUSH OPEN/CLOSE)
1-826-352-11
1-826-352-11
1-825-767-11
1-435-964-12
SPEAKER (10CM) (L-CH)
SPEAKER (10CM) (R-CH)
SPEAKER (10CM) (WOOFER)
TRANSFORMER, POWER
(G555CP:E92/G555CPK)
0 T901
1-435-965-11 TRANSFORMER, POWER (SP, E41, AUS)
*************************************************************
ACCESSORIES
***********
0
0
0
0
A-1072-204-A
1-575-131-11
1-590-342-11
1-782-126-11
1-827-945-11
REMOTE COMMANDER (RMT-CG550)
CORD, POWER (SP, E41)
CORD, POWER (G555CP:E92/G555CPK:MX)
CORD, POWER (CND)
CORD, POWER (AUS)
2-663-603-21 MANUAL, INSTRUCTION (ENGLISH, SPANISH)
(E92)
2-663-603-31 MANUAL, INSTRUCTION (ENGLISH)(SP, AUS)
2-663-603-41 MANUAL, INSTRUCTION (SPANISH)(E41)
2-663-603-51 MANUAL, INSTRUCTION (FRENCH)(SP)
2-663-603-61 MANUAL, INSTRUCTION (ENGLISH, FRENCH)
(CND)
2-663-603-71 MANUAL, INSTRUCTION (SPANISH)(G555CPK)
3-267-151-01 LID BATTERY (for RMT-CG550)
68
CFD-G555CP/G555CPK
MEMO
69
CFD-G555CP/G555CPK
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
Date
Description of Revision
1.0
2006.02
New
1.1
2006.04
Deletion of COVER (AC OUT)
Addition of Canadian model for CFD-G555CPK
(SPM-06042)