Download SERVICE MANUAL

SAVA-57
SERVICE MANUAL
• TRANSMITTER
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Chinese Model
• REAR SPEAKER
• FRONT SPEAKER SYSTEM
SPECIFICATIONS
HOME THEATER ACTIVE SPEAKER SYSTEM
MICROFILM
—1—
MODEL IDENTIFICATION
— BACK PANEL — (L-ch)
TABLE OF CONTENTS
1. SERVICING NOTE .......................................................... 3
2. GENERAL .......................................................................... 4
3. DISASSEMBLY
3-1. Front Panel Assembly ........................................................... 5
3-2. Amplifier Block .................................................................... 5
Parts No.
4. TEST MODE ....................................................................... 6
5. ELECTRICAL ADJUSTMENTS ................................. 6
6. DIAGRAMS
MODEL
US model
PARTS No.
4-991-281-0
CND model
4-991-281-1
AEP, UK, G, E, SP, MY,
TH, AUS model
CH model
6-1. Circuit Boards Location ........................................................ 8
6-2. Printed Wiring Board — Display Section — ........................ 9
6-3. Schematic Diagram — Display Section — ........................ 11
6-4. Schematic Diagram — Main Section — ............................ 13
6-5. Printed Wiring Board — Main Section — .......................... 17
6-6. Schematic Diagram — P. S Section — ............................... 20
6-7. Printed Wiring Board — P. S Section — ............................ 23
6-8. Printed Wiring Board — Transmitter Section — ................ 25
6-9. Schematic Diagram — Transmitter Section — .................. 27
6-10. Printed Wiring Board — Receiver Section — .................. 29
6-11. Schematic Diagram — Receiver Section — ..................... 31
6-12. IC Block Diagrams ............................................................ 33
6-13. IC Pin Function ................................................................. 36
4-991-281-2
4-991-281-3
• Abbreviation
CND : Canadian model.
G
: German model.
SP : Singapore model.
MY : Malaysia model.
TH : Thai model.
AUS : Australian model.
CH : Chinese model.
7. EXPLODED VIEWS
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
Front Speaker System (RIGHT) Section ............................ 37
Front Speaker System (LEFT) Section ............................... 38
Amplifier Section ................................................................ 39
Transmitter Section (EMT-VA57) ....................................... 40
Rear Speaker (PASSIVE) Section (SA-IF57) ..................... 41
Rear Speaker (ACTIVE) Section (SA-IF57) ...................... 42
8. ELECTRICAL PARTS LIST ........................................ 43
SAFETY-RELATED COMPONENT WARNING !!
ATTENTION AU COMPOSANT AYANT RAPPORT
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
QUE PAR DES PIÈCES SONY DONT LES NUMÉROS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
SONT DONNÉS DANS CE MANUEL OU DANS LES
À LA SÉCURITÉ!!
SUPPLÉMENTS PUBLIÉS PAR SONY.
—2—
SECTION 1
SERVICING NOTE
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth Ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale.
The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are suitable. (See Fig. A)
Connecting the Unit
• This unit is composed of a front speaker, transmitter and rear
speaker.
As the transmitter does not have its own power supply, connect it
to the front speaker as shown below when repairing.
• Connection
MAIN board J103
REAR SPEAKER
FRONT
SPEAKER
transmitter
Rear speaker
Auto Power Control of Rear Speaker
• As the rear speaker is equipped with an auto power control, it will
set into the STANDBY state if it does not receive carrier wave
from the transmitter.
When performing repairs, connect the units according to the using environment.
To Exposed Metal
Parts on Set
0.15µF
1.5kΩ
AC
voltmeter
(0.75V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
—3—
SECTION 2
GENERAL
Location of Parts and Controls
7
1
2
3
4
5
6
7
2
1
6
5
4
POWER button
MASTER VOL –/+ button
S.WOOFER button
CTR MODE button
Remote sensor
SURROUND button
INPUT button
3
This section is extracted from
instruction manual.
—4—
SECTION 3
DISASSEMBLY
3-1. FRONT PANEL ASSEMBLY
4 Front panel assembly
3 Four tapping screws
1 Ornamental panel
2 Two tapping screws
3-2. AMPLIFIER BLOCK
8 Back panel (L)
6 Three tapping screws
!¡ Amplifier block
3 Display panel assembly
7 Nine screws
(BVTP 3X8)
!º Connector
(CN01)
1 Two tapping
screws
5 Ten tapping screws
9 Three tapping screws
2 Two tapping screws
4 Flexible flat cable
(CN152)
—5—
SECTION 4
TEST MODE
SECTION 5
ELECTRICAL ADJUSTMENT
MODE ALL FLUORESCENT INDICATOR TUBES LIGHT
CARRIER FREQUENCY Adjustment
When the AC plug is inserted to the power outlet with pressing the
MASTER VOL + button, the all fluorescent indicator tubes light.
Note:
Set the transmitter to the user's environment, connect it to the front
speaker, and supply the power. (Refer to Service Note.)
KEY CHECK, LED LIGHTING MODE
Setting:
1. Pull out the AC plug from the power outlet and turn the power
OFF.
2. Connect the lead wire to TP3 on the KEY board.
3. Insert the AC plug to the power outlet and set to STANDBY
mode.
4. Let the lead wire connected in step 1 contact to the ground.
5. All fluorescent indicator tubes light, and enter the key check
mode.
6. Pressing any buttons, the number of button will be displayed on
the fluorescent indicator tube.
7. After all buttons are pressed, it will be in the STANDBY mode.
Button
Button Number
LED Color
POWER
2
Red
MASTER VOL –
3
Green
MASTER VOL +
4
Red
INPUT
5
Green
SURROUND
6
Red
CTR MODE
7
Green
S.WOOFER
8
Red
TP5
frequency counter
Transmitter
board
R226
TP6
Procedure:
1. Connect the frequency counter to TP5 and TP6 of the two ends
of the resistor (R226) of the TRANSMITTER board.
2. Turn ON the power of the front speaker.
3. Adjust L201 of the TRANSMITTER board, and adjust so that
the reading of the frequency counter is 4.3 MHz ± 0.01 MHz.
RECEIVING FREQUENCY, MUTING LEVEL adjustment
Note:
Perform procedure 1 if using FM RF SSG and procedure 2 if not.
However, as procedure 2 is a simple procedure, adjustment is not
accurate.
Note:
1. The LED (D505) lights while pressing each button.
The LED lights in red when even number of buttons are pressed,
and it lights in green when odd number of buttons are pressed.
2. The LED lights even when the pressed button is pressed again.
• Procedure 1
Setting:
FM RF SSG
level meter
TP7
Receiver
board
L1
Receiver
board
TP102
• Parts Location
[KEY BOARD] — Conductor side —
CN552
IC503
S506
R557
TP3
Carrier frequency : 4.3MHz
TP8
Modulation
: no moduration
Output level
: 40dB (at 75 Ω open)
Procedure:
1. Connect SSG to TP7 and TP8 of the two ends of the coil (L1) of
the RECEIVER board.
2. Set the output level of SSG to 40 dB.
3. Insert the AC plug of the unit to the power outlet and supply the
power.
4. Adjust IFT103 of the RECEIVER board, and adjust so that the
voltage of both ends of TP102 becomes 0V. (RECEIVING FREQUENCY adjustment)
5. Adjust the output level of SSG to 22 dB.
6. Adjust RV102 until D109 turns green from red. (MUTING
LEVEL adjustment)
—6—
• Procedure 2
Note:
The adjustment results of this procedure differs according to the
distance between the transmitter and rear speaker.
Leave ample distance between the transmitter and rear speaker according to the user's using environment when performing the adjustment.
Procedure:
1. Connect the transmitter to the front speaker and turn the power
supply on.
2. Adjust IFT103 of the RECEIVER board, and adjust so that the
voltage of the two ends of TP102 becomes 0V. (RECEIVING
FREQUENCY adjustment)
3. Adjust RV102 of the RECEIVER board of the rear speaker until
D109 turns green. (MUTING LEVEL adjustment)
4. Turn OFF the power turned on at STEP 1.
5. Check that D109 of the RECEIVER board of the rear speaker
becomes red.
If green, adjust RV102 so that it turns red, turn ON the power
again, and repeat from step 3.
6. After adjusting, check that D109 becomes red when the power
of the front speaker is turned OFF and it becomes green when
the power is turned ON.
Reference Information:
For this adjustment, the reaching distance of the infrared rays increases when the MUTING LEVEL (sensitivity) is raised, but if the
power of the front speaker is turned OFF, pop noises are produced
from the rear speaker.
If the MUTING LEVEL (sensitivity) is dropped on the other hand,
pop noises are reduced, but the reaching distance of the infrared
rays decreases.
Adjust according to the user's using environment.
[RECEIVER BOARD] — Component side —
JW107
TP8
L1
TP7
D1
JW111
JW108
JW132
JW109
JW110
RECEIVING
FREQUENCY
&
IC104
MUTING
LEVEL
JW112
JW133
JW113
JW114
SCN101
RV102
MUTING
LEVEL
IFT103
RECEIVING
FREQUENCY
TP102
JW115
JW116
JW117
JW119
JW120
JW121
JW118
JW122
[TRANSMITTER BOARD] — Component side —
IC202
CN201
L201
R226
TP5
TP6
CARRIER FREQUENCY
—7—
SECTION 6
DIAGRAMS
6-1. CIRCUIT BOARDS LOCATION
POWER FR board
MAIN board
DOLBY board
DISPLAY board
POWER SW board
P. S board
T1 board
KEY board
T2 board
(L-CH)
(L-CH)
RECEIVER board
(including pA)
AMPLIFIER board
TRANSMITTER board
pA
LED board
—8—
6-12. IC BLOCK DIAGRAMS
IC104 LA1235
16
IC202 M5218AL
15 14 13
12 11 10 9
B+
MUTING
CIRCUIT
IF OFF
NULL METER
SHORTING
FM IF AMP
LIMITER
6
7
8
OUT2
V+
5
–IN2
4
3
+IN1
+IN2
2
–IN1
V–
1
OUT1
DETUNE
DET
METER
DRIVE
LEVEL
DET
IC301 LA2786
AF/NULL
METER
QUADRATURE
DET
AF AMP
GND
6
BPF1
BPF2
7 8
1
2
VREF
3
S-CH DC OUT
C-CH DC OUT
L-CH DC OUT
R-CH DC OUT
VREF
4
5
6
7
8
L-IN
9
R-IN
10
VSS
11
NOISE
FILTER
NOISE
CH
V REF
BALANCE
CONTROL
NOISE
GENERATOR
IC105 TK10691MTL
IC203 TK10690MTL
NF IN
INPUT
DIVIDER
1
8
2
VCC
7
OUTPUT
6
CONT IN
5
RECT CAP
G SELL
REF CAP
3
VREF
RECT
4
VR
VR
LCOM
LT1
LT2
LT3
LTOUT
LSIN
LS1
LS2
LS3
LSOUT
32
31 30
29
28 27 26
25 24
23
+
–
+
–
34
35
36
37
38
+
–
22 LFIN
–
+
+
–
21 LFOUT
+
–
20 LROUT
19 VREF
VDD 39
–
+
–
+
LATCH
SHIFT
REGISTER
+
–
–
+
+
–
–
+
+
–
5
RT1
RT2
RT3
6 7 8
9 10
11
RSOUT
3 4
— 33 —
VCA
VCA
VCA
VCA
VCA
VCA
VCA
18
17
16
15
CE
DI
CL
VSS
14 RROUT
L-BPF1
12
L-BPF2
L-BPF3
13
14
DC CUT
DC CUT
R RECT
L RECT
15
16
17
18
VLR-TH
19
VLR-1
VLR-2
20
21
CLK
OSC
39
OSC1
38
VCC
37
L-OUT
36
R-OUT
35
S-OUT
DATA
ENABLE
34
C-OUT
33
32
CMODE-CAP.
C-TRIM DC CUT
31
R-BPF1
30
29
R-BPF2
R-BPF3
28
27
26
25
DC CUT
24
VCS-TH
23
22
VCS-1
VCS-2
LPF
RECT
LOG
DIFF
RECT
–
+
RECT
RECT
LOG
DIFF
13 RFOUT
12 RFIN
RS2
RS3
2
RCOM
–
+
1
CONTROL
–
+
RTOUT
RSIN
RS1
40
41
42
43
44
RVRIN
R1
R2
R3
R4
RSELO
DECODER
VCA
LPF
–
+
–
+
–
+
LSELO
L4
L3
L2
L1
P. S.
LVRIN
IC201, 251 LC75373ED
33
42
41
40
VR
CONTROL
P. S.
GND
LPF
CONTROL
5
CTRIM
4
MUTE
3
CMODE
2
DUAL T
CONTROL
1
— 34 —
DC CUT
L-R RECT
L+R RECT
VCC 1
NC 2
OUTPUT 3
VEE 4
NC 5
NC 6
GND 7
MUTE 8
IN– 9
IN+ 10
STANDBY 11
IC301 LM4700TF
IC302, 701 µPC1237HA
OVER LOAD DET
VCC ON
MUTE
F/F
OFFSET DET
LATCH/
AUTORESET
AC OFF
DET
VCC
1
2
3
4
5
6
7
8
19
S-OUT
20
VREF
21
R-OUT
22
L-OUT
VDD
23
A.GND
OSC
24
DC-CUT
OSC
IC351 LV1016
18
17
16
15
14
13
ADM
A
B
A
INV-PHASE
SRAM
+
+
L+DELAY
R+DELAY
A
B
A
ADM-CONT
B
VDD
A
B
VOL/MUTE
B
OUT-FILTER
(7k/5k)
–
IN-FILTER
(40kHz)
DC-OUT
L–R
S-TRIM
+
L+R
(–6dB)
A
4
5
6
7
8
9
10
11
12
ENABLE
NR-DET
NR-IREF
VCC
L-IN
R-IN
S-IN
DELAY-OUT
DC-CUT
B
3
CLK
B
2
DATA
A
A
1
D.GND
DEC
B
B-NR
— 35 —
6-13. IC PIN FUNCTIONS
• IC501 SYSTEM CONTROL (uPD78043FGF-012-3B9)
Pin No.
1-7
Pin Name
7G-1G
I/O
Function
O
FL gride signal output
8
VDD
–
Power supply (+4.7V)
9
POWER RY
O
Power relay output
10
PLO/DELAY-CE
O
Dolby IC enable output
11
PLO/DELAY-DATA
O
Dolby IC data output
12
PLO/DELAY-CLK
O
Dolby IC clock output
13
FRONT MUT
O
Front speaker mute output
14
CENTER MUT
O
Senter speaker mute output
15
HCD IN
I
HCD connector input
16
S/W MUT
O
Super woofer mute output
17
RESET
I
Reset signal input
18
—
–
Connected to ground
19
—
–
Connected to ground
20
AVSS
–
Ground
21
VOL CE
O
Volume IC enable output
22
VOL DI1
O
Volume IC data output 2
23
VOL CL1
O
Volume IC clock output 2
24
VOL DI2
O
Volume IC data output 1
25
VOL CL2
O
Volume IC clock output 1
26
AUTO SW
I
Line input level
27
KEY 1
I
AD input for key
28
KEY 0
I
AD input for key
29
AVDD
–
Power supply (+4.7V)
30
AVREF
I
Analog reference voltage input
31
STOP
I
STOP input
32
XT2
–
Not used
33
VSS
–
Ground
34
X1
I
X’tal (5MHz)
35
X2
O
X’tal (5MHz)
36
REAR MUT
O
Rear speaker mute
37
REAR POWER
O
Connected to ground
38
S/W BOOST
O
Super woofer boost
39
—
–
Power supply (+4.7V)
40
CENTER EXT-SW
I
External center speaker switch input
41
TV/SW
I
TV SIRCS enable switch input
42
—
–
Connected to ground
43
—
–
Connected to ground
44
INT SIRCS
I
SIRCS input
45
—
–
Connected to ground
46
—
–
Connected to ground
47
—
–
Connected to ground
48
IC
–
Connected to ground
49
STANDBY LED
O
LED output
50
READY LED
O
LED output
51
OPRATE LED
O
LED output
52
VDD
–
Power supply (+4.7V)
53-70
S24-S7
O
FL segment signal output
71
VLOAD
–
Power supply (–25V) for FL segment signal output
S6-S1
O
FL segment signal output
10G-8G
78-80
• Abbreviation
FL : Fluorescent indicator tube
O
FL gride signal output
72-77
— 36 —
SECTION 7
EXPLODED VIEWS
NOTE:
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• The mechanical parts with no reference number in
the exploded views are not supplied.
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
• Abbreviation
CND : Canadian model
G
: German model
SP
: Singapore model
MY : Malaysia model
AUS : Australian model
CH : Chinese model
TH : Thai model
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
7-1. FRONT SPEAKER SYSTEM (RIGHT) SECTION
19
17
19
19
SP902
19
13
19
12
11
16
19
SP903
18
SP904
18 19
19
15
SP901
2
16
18
16
19
10
18
19
4
5
14
19
19
1
19
15
7
19
6
9
19
19
8
3
8
Ref. No.
#1
#1
19
Part No.
Description
1
2
3
4
5
4-991-264-01
X-4948-548-1
X-4948-546-1
4-951-733-01
X-4948-709-1
PANEL, ORNAMENTAL
FRAME (R) ASSY, GRILLE
PANEL ASSY, FRONT
CATCHER
PANEL (R) ASSY
* 6
* 7
8
9
10
4-991-267-01
4-992-596-01
4-967-287-01
4-991-263-01
1-782-666-11
DUCT (C)
PACKING (C)
CUSHION (A)
BASE
CORD
* 11
* 12
4-975-267-01 FRAME, SPEAKER
4-975-307-01 PACKING (SPEAKER FRAME)
Remark
Ref. No.
Part No.
* 13
* 14
* 14
4-991-262-01 PANEL, TOP
X-4949-205-1 CABINET (R) ASSY, SPEAKER (EXCEPT G)
X-4949-207-1 CABINET (R) ASSY, SPEAKER (G)
* 15
* 16
* 17
18
19
4-991-285-01
4-992-597-01
4-991-282-01
4-874-614-61
4-914-430-11
COVER (SW)
PACKING (SW)
PANEL (R), BACK
SCREW +BVTP 3.5X16
SCREW (4X20), TAPPING
1-505-654-11
1-505-655-11
1-505-656-11
1-505-657-11
SPEAKER (5cm)
SPEAKER (10cm)
SPEAKER (12cm)
SPEAKER (16cm)
SP901
SP902
SP903
SP904
— 37 —
Description
Remark
7-2. FRONT SPEAKER SYSTEM (LEFT) SECTION
77
72
71
70
77
77
77
77
SP908
77
#3
#3
#3
68
69
#3 74
77
SP906
76
#3
SP907
76 SP905
76
77
77
77
75
#2
52
77
66
76
56
55
FL501
58 #2
57
77
67
54
66
60
77
51
66
77
61
59 77
77
65
62
78
77
64
77
63
53
77
77
#1
#1
64
Ref. No.
Part No.
Description
51
52
53
54
* 55
4-991-264-01
X-4948-547-1
X-4948-546-1
4-951-733-01
A-4403-006-A
PANEL, ORNAMENTAL
FRAME (L) ASSY, GRILLE
PANEL ASSY, FRONT
CATCHER
DISPLAY BOARD, COMPLETE
* 56
57
58
59
* 60
4-991-276-01
X-4948-550-1
4-991-284-01
4-991-275-01
1-666-222-11
HOLDER, FL TUBE
PANEL ASSY, DISPLAY
REFLECTOR
WINDOW (IR)
KEY BOARD
61
62
* 63
64
65
4-991-271-01
4-991-272-01
4-991-267-01
4-967-287-01
4-991-263-01
BUTTON (A)
BUTTON (B)
DUCT (C)
CUSHION (A)
BASE
* 66
* 67
68
* 69
4-992-597-01
4-991-285-01
1-782-666-11
4-975-267-01
PACKING (SW)
COVER (SW)
CORD
FRAME, SPEAKER
77
67
Remark
Ref. No.
Part No.
* 70
4-975-307-01 PACKING (SPEAKER FRAME)
Description
Remark
*
*
*
*
*
71
72
72
73
74
4-991-262-01
X-4949-204-1
X-4949-206-1
4-991-282-01
4-976-741-01
PANEL, TOP
CABINET (L) ASSY, SPEAKER (EXCEPT G)
CABINET (L) ASSY, SPEAKER (G)
PANEL (R), BACK
COVER, BUTTON
*
*
*
*
75
75
75
75
76
4-991-281-01
4-991-281-11
4-991-281-21
4-991-281-31
4-874-614-61
PANEL (L), BACK (US)
PANEL (L), BACK (CND)
PANEL (L), BACK (AEP,UK,G,E,SP,MY,TH,AUS)
PANEL (L), BACK (CH)
SCREW +BVTP 3.5X16
77
* 78
FL501
SP905
SP906
4-914-430-11
4-992-596-01
1-517-673-11
1-505-654-11
1-505-655-11
SCREW (4X20), TAPPING
PACKING (C)
INDICATOR TUBE, FLUORESCENT
SPEAKER (5cm)
SPEAKER (10cm)
SP907
SP908
— 38 —
1-505-656-11 SPEAKER (12cm)
1-505-657-11 SPEAKER (16cm)
7-3. AMPLIFIER SECTION
#3
105
not supplied
not supplied
not supplied
#3
#3
#3
#3
#3
#5
103
#3
not
supplied
111
#3
#3
#3
#5
#3
104
107
#5
not
supplied
#3
102
106
101
#3
108
#4
#3
109
#4
#3
110 (AEP, G, E, SP, MY, TH, AUS)
110 (CH)
T901
#3
110 (UK)
110 (US, CND)
not supplied
#3
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Ref. No.
*
*
*
*
*
101
102
103
104
105
* 106
* 106
* 107
* 108
Part No.
Description
1-666-220-11
1-666-219-11
A-4403-007-A
A-4403-008-A
A-4403-001-A
T2 BOARD
T1 BOARD
POWER FR BOARD, COMPLETE
POWER SW BOARD, COMPLETE
DOLBY BOARD, COMPLETE
Remark
A-4403-000-A MAIN BOARD, COMPLETE (US,CND)
A-4403-009-A MAIN BOARD, COMPLETE
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
4-975-298-01 BUTTON (PUSH)
A-4403-002-A P.S BOARD, COMPLETE
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
Ref. No.
Part No.
* 109
3-703-244-00 BUSHING (2104), CORD
! 110
! 110
! 110
! 110
111
1-575-042-21
1-575-651-21
1-751-529-11
1-782-510-11
1-773-274-11
! T901
! T901
1-431-429-11 TRANSFORMER, POWER (US,CND)
1-431-438-11 TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
— 39 —
Description
Remark
CORD, POWER (US,CND)
CORD, POWER (AEP,G,E,SP,MY,TH,AUS)
CORD, POWER (UK)
CORD, POWER (CH)
WIRE (FLAT TYPE) (27 CORE)
7-4. TRANSMITTER SECTION (EVT-VA57)
155
CNP201
156
154
157
153
158
#6
151
#6
152
not supplied
#6
#6
Ref. No.
151
152
153
154
155
Part No.
Description
4-991-626-01
4-991-621-01
4-991-624-01
4-991-627-01
4-991-623-11
SPRING, CLICK
HOLDER, STAND
CASE (BOTTOM)
COVER (FRONT)
CASE (TOP)
Remark
Ref. No.
Part No.
Description
* 156
* 157
158
CNP201
A-4403-191-A
1-666-727-11
4-991-622-01
1-782-270-11
TRANSMITTER BOARD, COMPLETE
LED BOARD
STAND
CORD, CONNECTION (TRANSMITTER 3.5m)
— 40 —
Remark
7-5. REAR SPEAKER (PASSIVE) SECTION (SA-IF57)
#7
204
not supplied
#8
#8
#7
203
#7
202
#8
#8
#7
207
203
206
208
205
#7
#7
#7
209
201
SP301
Ref. No.
Part No.
Description
201
* 202
203
204
205
X-4948-573-1
X-4948-572-1
4-991-610-01
1-537-775-11
1-775-758-11
PANEL ASSY, FRONT
CABINET ASSY, SPEAKER
PACKING (CABINET)
TERMINAL BOARD
LEAD (WITH CONNECTOR)
Remark
Ref. No.
*
*
*
*
206
207
208
209
SP301
— 41 —
Part No.
Description
4-991-614-21
4-991-617-01
3-846-312-01
4-994-861-01
1-505-643-11
PANEL, REAR
CABINET (REAR)
SPACER
PLUG, DUCT
SPEAKER (10cm)
Remark
7-6. REAR SPEAKER (ACTIVE) SECTION (SA-IF57)
255
not supplied
256
#8
260
#8
#7
#7
261 (US, CND)
#8
#8
#7
#8
254
261 (CH)
259
#8
#8
#7
252
261 (AEP, UK, G, E, SP, MY, TH, AUS)
#8
262
263
#7
264
not supplied
not supplied
258
T301
#7
#8
#7
253
#8
251
257
SP302
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
251
* 252
253
* 254
255
X-4948-571-1
A-4398-847-A
3-905-609-01
X-4948-572-1
4-991-610-01
PANEL ASSY, FRONT
RECEIVER BOARD, COMPLETE
SCREW (TRANSISTOR)
CABINET ASSY, SPEAKER
PACKING (CABINET)
256
* 257
* 258
259
1-537-775-11
A-4398-841-A
4-994-861-01
3-703-244-00
259
Remark
TERMINAL BOARD
AMPLIFIER BOARD, COMPLETE
PLUG, DUCT
BUSHING (2104), CORD
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
3-703-571-00 BUSHING (S) 4516, CORD (US,CND)
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
Ref. No.
Part No.
Description
* 260
! 261
! 261
! 261
* 262
4-991-617-01
1-782-510-11
1-782-603-11
1-782-604-11
4-991-614-11
CABINET (REAR)
CORD, POWER (CH)
CORD, POWER (AEP,UK,G,E,SP,MY,TH,AUS)
CORD, POWER (US,CND)
PANEL, REAR
263
! 264
SP302
! T301
3-846-312-01
1-770-019-11
1-505-643-11
1-431-342-11
! T301
— 42 —
Remark
SPACER
ADAPTOR, CONVERSION PLUG 3P (UK)
SPEAKER (10cm)
TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-431-343-11 TRANSFORMER, POWER (US,CND)
SECTION 8
ELECTRICAL PARTS LIST
AMPLIFIER
DISPLAY
Note:
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
When indicating parts by reference
number, please include the board
name.
• Due to standardization, replacements in the parts list
may be different from the parts specified in the
diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• CAPACITORS
uF : µ F
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Ref. No.
Part No.
Description
Remark
*
A-4398-841-A AMPLIFIER BOARD, COMPLETE
**************************
Ref. No.
FH301
FH302
C301
C302
C303
C304
C305
1-162-294-31
1-104-664-11
1-128-560-11
1-126-965-11
1-126-965-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
0.001uF
47uF
22uF
22uF
22uF
10%
20%
20%
20%
20%
50V
25V
100V
50V
50V
C306
C307
C308
C309
C310
1-136-165-00
1-126-933-11
1-126-960-11
1-104-664-11
1-126-955-11
FILM
ELECT
ELECT
ELECT
ELECT
0.1uF
100uF
1uF
47uF
4700uF
5%
20%
20%
20%
20%
50V
16V
50V
25V
35V
C311
C312
C313
C314
C315
1-126-955-11
1-126-942-61
1-126-935-11
1-104-664-11
1-136-165-00
ELECT
ELECT
ELECT
ELECT
FILM
4700uF
1000uF
470uF
47uF
0.1uF
20%
20%
20%
20%
5%
35V
25V
16V
25V
50V
C316
C317
C318
C320
1-136-165-00
1-136-165-00
1-137-372-11
1-162-282-31
FILM
FILM
FILM
CERAMIC
0.1uF
0.1uF
0.022uF
100PF
5%
5%
5%
10%
50V
50V
50V
50V
1-533-293-11 FUSE HOLDER
1-533-293-11 FUSE HOLDER
< IC >
IC301
IC302
IC303
8-759-467-10 IC LM4700TF
8-759-111-68 IC uPC1237HA
8-759-604-40 IC M5F78M15
R301
R302
R303
R304
R305
1-249-429-11
1-247-863-91
1-249-417-11
1-247-863-91
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
22K
1K
22K
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
R306
R307
R308
R309
R310
1-249-441-11
1-247-807-31
1-249-429-11
1-249-435-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100
10K
33K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R311
! R312
R313
R314
R315
1-249-441-11
1-215-865-11
1-249-381-11
1-247-863-91
1-247-863-91
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
100K
220
1
22K
22K
5%
5%
5%
5%
5%
1/4W
1W
F
1/4W F
1/4W
1/4W
PLUG (MICRO CONNECTOR) 6P
PIN, CONNECTOR (PC BOARD) 2P
PLUG, CONNECTOR 2P
PLUG, CONNECTOR 2P
< RELAY >
RY301
1-755-142-11 RELAY
< DIODE >
D301
D302
D303
D304
D305
8-719-028-23
8-719-987-63
8-719-987-63
8-719-987-63
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
D3SBA20-4101
1N4148M
1N4148M
1N4148M
11ES2
D306
D307
D308
D309
D310
8-719-200-82
8-719-200-82
8-719-200-82
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
1N4148M
1N4148M
Remark
< RESISTOR >
< CONNECTOR >
1-691-768-11
1-580-230-31
1-564-505-11
1-564-505-11
Description
< FUSE HOLDER >
< CAPACITOR >
CN301
* CN302
CN303
CN304
Part No.
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• COILS
uH : µ H
• Abbreviation
CND : Canadian model
G
: German model
SP
: Singapore model
MY : Malaysia model
AUS : Australian model
CH : Chinese model
TH : Thai model
< TRANSFORMER >
! T301
! T301
1-431-342-11 TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-431-343-11 TRANSFORMER, POWER (US,CND)
**************************************************************
*
A-4403-006-A DISPLAY BOARD, COMPLETE
************************
*
4-991-276-01 HOLDER, FL TUBE
< CAPACITOR >
< FUSE >
! F301
! F301
1-532-389-51 FUSE TIME-LAG (T0.5AL/250V)
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-576-100-11 FUSE (1A/250V)(US,CND)
C501
C502
C503
C504
— 43 —
1-124-261-00
1-124-261-00
1-164-159-21
1-164-159-21
ELECT
ELECT
CERAMIC
CERAMIC
10uF
10uF
0.1uF
0.1uF
20%
20%
50V
50V
50V
50V
DISPLAY
Ref. No.
DOLBY
Part No.
Description
Remark
C505
1-164-159-21 CERAMIC
0.1uF
C506
C507
C508
C509
C510
1-126-154-11
1-104-905-11
1-164-159-21
1-124-465-00
1-164-159-21
47uF
0.22F
0.1uF
0.47uF
0.1uF
C512
C513
1-164-159-21 CERAMIC
1-126-154-11 ELECT
ELECT
CAPACITOR
CERAMIC
ELECT
CERAMIC
0.1uF
47uF
Ref. No.
50V
20%
20%
20%
6.3V
5.5V
50V
50V
50V
50V
6.3V
< CONNECTOR >
* CN152
* CN501
1-568-869-11 SOCKET, CONNECTOR 27P
1-564-710-11 PIN, CONNECTOR 8P
< DIODE >
D501
D502
D503
D506
D507
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
1N4148M
1N4148M
1N4148M
< FLUORESCENT INDICATOR >
FL501
1-517-673-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC501
IC502
8-759-463-21 IC uPD78043FGF-021-3B9
8-759-165-81 IC PST600D-T
Part No.
Description
Remark
R519
R520
R521
1-249-417-11 CARBON
1-249-429-11 CARBON
1-249-429-11 CARBON
1K
10K
10K
5%
5%
5%
1/4W F
1/4W
1/4W
R522
R526
R534
R535
R536
1-247-843-11
1-247-843-11
1-247-815-91
1-249-407-11
1-247-815-91
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
3.3K
220
150
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R537
R538
R539
R540
R541
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R542
R543
R544
R545
R546
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R547
R548
R549
R550
R551
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R552
R553
R554
R555
R556
1-249-437-11
1-249-437-11
1-249-437-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
1K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R560
R561
R562
R563
R564
1-249-413-11
1-249-413-11
1-249-437-11
1-249-437-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
470
470
47K
47K
100
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
R565
R566
R570
R571
R572
1-247-807-31
1-249-425-11
1-247-895-91
1-247-895-91
1-249-419-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
4.7K
470K
470K
1.5K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R573
R574
R575
1-249-419-11 CARBON
1-249-437-11 CARBON
1-249-437-11 CARBON
1.5K
47K
47K
5%
5%
5%
1/4W
1/4W
1/4W
< COIL >
L501
1-410-521-11 INDUCTOR
100uH
< TRANSISTOR >
Q501
Q503
Q504
Q505
Q506
8-729-119-79
8-729-900-63
8-729-141-30
8-729-141-30
8-729-900-63
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-FEK
DTA124ES
2SC3623-LK
2SC3623-LK
BN1F4M-TP
Q507
8-729-900-36 TRANSISTOR DTC124ES
< RESISTOR >
R501
R502
R503
R504
R505
1-249-417-11
1-247-807-31
1-247-807-31
1-247-807-31
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100
100
100
1K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W F
R506
R507
R508
R509
R510
1-249-417-11
1-249-417-11
1-247-807-31
1-247-807-31
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
100
100
1K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W F
R511
R512
R513
R514
R515
1-249-417-11
1-247-807-31
1-247-807-31
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100
100
1K
1K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
C301
C302
C303
C304
C305
1-136-157-00
1-136-161-00
1-126-934-11
1-117-910-11
1-117-910-11
R516
R518
1-249-417-11 CARBON
1-249-417-11 CARBON
1K
1K
5%
5%
1/4W F
1/4W F
C306
C307
1-117-910-11 ELECT
1-117-910-11 ELECT
< VIBRATOR >
X501
1-579-233-11 VIBRATOR, CERAMIC (5MHz)
**************************************************************
A-4403-001-A DOLBY BOARD, COMPLETE
**********************
*
< CAPACITOR >
— 44 —
FILM
FILM
ELECT
ELECT
ELECT
0.022uF
0.047uF
220uF
10uF
10uF
5%
5%
20%
20%
20%
50V
50V
16V
50V
50V
10uF
10uF
20%
20%
50V
50V
DOLBY
Ref. No.
Part No.
Description
Remark
C308
C309
C310
1-126-934-11 ELECT
1-126-960-11 ELECT
1-126-960-11 ELECT
220uF
1uF
1uF
20%
20%
20%
16V
50V
50V
C311
C312
C313
C314
C315
1-136-165-00
1-136-165-00
1-126-959-11
1-126-963-11
1-126-959-11
FILM
FILM
ELECT
ELECT
ELECT
0.1uF
0.1uF
0.47uF
4.7uF
0.47uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C316
C317
C318
C319
C320
1-126-963-11
1-136-167-00
1-126-962-11
1-136-167-00
1-136-167-00
ELECT
FILM
ELECT
FILM
FILM
4.7uF
0.15uF
3.3uF
0.15uF
0.15uF
20%
5%
20%
5%
5%
50V
50V
50V
50V
50V
C321
C322
C323
C324
C325
1-126-962-11
1-136-167-00
1-126-963-11
1-126-959-11
1-126-963-11
ELECT
FILM
ELECT
ELECT
ELECT
3.3uF
0.15uF
4.7uF
0.47uF
4.7uF
20%
5%
20%
20%
20%
50V
50V
50V
50V
50V
C326
C327
C328
C329
C330
1-126-959-11
1-136-165-00
1-136-165-00
1-104-664-11
1-126-959-11
ELECT
FILM
FILM
ELECT
ELECT
0.47uF
0.1uF
0.1uF
47uF
0.47uF
20%
5%
5%
20%
20%
50V
50V
50V
25V
50V
C331
C333
C334
C351
C352
1-126-960-11
1-126-934-11
1-162-292-31
1-126-961-11
1-126-934-11
ELECT
ELECT
CERAMIC
ELECT
ELECT
1uF
220uF
680PF
2.2uF
220uF
20%
20%
10%
20%
20%
50V
16V
50V
50V
16V
C354
C355
C356
C357
C358
1-136-165-00
1-136-171-00
1-126-934-11
1-126-960-11
1-126-960-11
FILM
FILM
ELECT
ELECT
ELECT
0.1uF
0.33uF
220uF
1uF
1uF
5%
5%
20%
20%
20%
50V
50V
16V
50V
50V
C359
C360
C361
C362
C363
1-126-960-11
1-136-173-00
1-136-164-00
1-137-367-11
1-136-164-00
ELECT
FILM
FILM
FILM
FILM
1uF
0.47uF
0.082uF
0.0033uF
0.082uF
20%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C364
C365
C366
1-126-934-11 ELECT
1-162-294-31 CERAMIC
1-164-159-21 CERAMIC
220uF
1000PF
0.1uF
20%
10%
16V
50V
50V
Ref. No.
R357
R358
Part No.
KEY
Description
1-247-903-00 CARBON
1-247-807-31 CARBON
LED
Remark
1M
100
5%
5%
1/4W
1/4W
< VIBRATOR >
X351
1-579-125-11 VIBRATOR, CERAMIC (8MHz)
**************************************************************
1-666-222-11 KEY BOARD
*********
*
< CAPACITOR >
C511
1-162-306-11 CERAMIC
0.01uF
20%
16V
< DIODE >
D504
D505
8-719-313-43 DIODE SEL6210S-TH10 (STANDBY)
8-719-045-89 DIODE SML16760CN (ON/READY)
< IC >
IC503
< RESISTOR >
R523
R524
R525
R527
R528
1-249-415-11
1-249-417-11
1-249-419-11
1-249-415-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
1K
1.5K
680
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R529
R557
R567
1-249-419-11 CARBON
1-249-429-11 CARBON
1-249-417-11 CARBON
1.5K
10K
1K
5%
5%
5%
1/4W F
1/4W
1/4W F
S501
S502
S503
S504
S505
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
SWITCH, TACT (INPUT)
SWITCH, TACT (S.WOOFER)
SWITCH, TACT (SURROUND)
SWITCH, TACT (CTR MODE)
SWITCH, TACT (MASTER VOL +)
S506
S507
1-762-196-21 SWITCH, TACT (MASTER VOL −)
1-762-196-21 SWITCH, TACT (POWER)
**************************************************************
1-666-727-11 LED BOARD
*********
*
1-770-731-11 CONNECTOR, BOARD TO BOARD 12P
< DIODE >
< IC >
IC301
IC351
8-759-442-96 IC LA2786
8-759-442-97 IC LV1016
< COIL >
L301
L351
1-408-117-00 INDUCTOR
1-408-117-00 INDUCTOR
10uH
10uH
< RESISTOR >
R354
R355
R356
1-249-436-11 CARBON
1-249-431-11 CARBON
1-249-439-11 CARBON
39K
15K
68K
5%
5%
5%
F
F
F
F
F
< SWITCH >
< CONNECTOR >
CN251
8-759-339-53 IC GP1U28XB
1/4W
1/4W
1/4W
D501
D502
D503
D504
D505
8-719-992-14
8-719-992-14
8-719-992-14
8-719-992-14
8-719-992-14
DIODE
DIODE
DIODE
DIODE
DIODE
LIR5BEA
LIR5BEA
LIR5BEA
LIR5BEA
LIR5BEA
D506
D511
D512
D513
D514
8-719-992-14
8-719-992-14
8-719-992-14
8-719-992-14
8-719-992-14
DIODE
DIODE
DIODE
DIODE
DIODE
LIR5BEA
LIR5BEA
LIR5BEA
LIR5BEA
LIR5BEA
D515
D516
8-719-992-14 DIODE LIR5BEA
8-719-992-14 DIODE LIR5BEA
— 45 —
LED
Ref. No.
MAIN
Part No.
Description
Remark
< TRANSISTOR >
Q501
Q502
Q503
Q504
8-729-111-29
8-729-111-29
8-729-111-29
8-729-111-29
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1616A-K
2SD1616A-K
2SD1616A-K
2SD1616A-K
< RESISTOR >
R501
R502
R503
R504
1-249-395-11
1-249-395-11
1-249-395-11
1-249-395-11
CARBON
CARBON
CARBON
CARBON
15
15
15
15
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
**************************************************************
A-4403-009-A MAIN BOARD, COMPLETE
*********************
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
*
A-4403-000-A MAIN BOARD, COMPLETE (US,CND)
******************************
*
Ref. No.
Part No.
Description
Remark
C258
C259
C260
C262
C263
1-126-964-11
1-137-367-11
1-136-157-00
1-126-960-11
1-126-960-11
ELECT
FILM
FILM
ELECT
ELECT
10uF
0.0033uF
0.022uF
1uF
1uF
20%
5%
5%
20%
20%
50V
50V
50V
50V
50V
C265
C266
C281
C282
C283
1-126-960-11
1-128-551-11
1-126-960-11
1-136-161-00
1-136-161-00
ELECT
ELECT
ELECT
FILM
FILM
1uF
22uF
1uF
0.047uF
0.047uF
20%
20%
20%
5%
5%
50V
25V
50V
50V
50V
C284
C285
C288
C289
C290
1-136-163-00
1-136-163-00
1-136-161-00
1-136-161-00
1-126-960-11
FILM
FILM
FILM
FILM
ELECT
0.068uF
0.068uF
0.047uF
0.047uF
1uF
5%
5%
5%
5%
20%
50V
50V
50V
50V
50V
C291
C293
C294
C296
C297
1-126-960-11
1-126-960-11
1-126-960-11
1-126-960-11
1-162-294-31
ELECT
ELECT
ELECT
ELECT
CERAMIC
1uF
1uF
1uF
1uF
1000PF
20%
20%
20%
20%
10%
50V
50V
50V
50V
50V
C403
C404
C405
C406
C407
1-136-167-00
1-136-167-00
1-136-167-00
1-136-167-00
1-126-960-11
FILM
FILM
FILM
FILM
ELECT
0.15uF
0.15uF
0.15uF
0.15uF
1uF
5%
5%
5%
5%
20%
50V
50V
50V
50V
50V
C421
C422
C431
C432
C441
1-126-960-11
1-126-961-11
1-126-960-11
1-126-961-11
1-126-960-11
ELECT
ELECT
ELECT
ELECT
ELECT
1uF
2.2uF
1uF
2.2uF
1uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C442
C451
C452
C453
C460
1-126-961-11
1-126-960-11
1-126-961-11
1-126-960-11
1-126-961-11
ELECT
ELECT
ELECT
ELECT
ELECT
2.2uF
1uF
2.2uF
1uF
2.2uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C461
C462
C463
C801
C803
1-126-960-11
1-162-282-31
1-162-282-31
1-104-664-11
1-126-959-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
1uF
100PF
100PF
47uF
0.47uF
20%
10%
10%
20%
20%
50V
50V
50V
25V
50V
C908
C921
C922
C923
1-104-664-11
1-104-664-11
1-126-941-11
1-104-664-11
ELECT
ELECT
ELECT
ELECT
47uF
47uF
470uF
47uF
20%
20%
20%
20%
25V
25V
25V
25V
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
C101
C102
C109
C110
C161
1-162-286-21
1-162-286-21
1-126-960-11
1-126-960-11
1-162-286-21
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
220PF
220PF
1uF
1uF
220PF
10%
10%
20%
20%
10%
50V
50V
50V
50V
50V
C162
C166
C167
C168
C201
1-162-286-21
1-126-964-11
1-126-964-11
1-126-964-11
1-126-960-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
220PF
10uF
10uF
10uF
1uF
10%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C203
C204
C205
C207
C208
1-126-960-11
1-126-933-11
1-126-960-11
1-126-960-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
1uF
100uF
1uF
1uF
10uF
20%
20%
20%
20%
20%
50V
16V
50V
50V
50V
C211
C212
C213
C214
C215
1-126-960-11
1-126-960-11
1-136-169-00
1-136-169-00
1-126-960-11
ELECT
ELECT
FILM
FILM
ELECT
1uF
1uF
0.22uF
0.22uF
1uF
20%
20%
5%
5%
20%
50V
50V
50V
50V
50V
C216
C219
C220
C221
C222
1-126-964-11
1-126-960-11
1-137-367-11
1-126-960-11
1-126-960-11
ELECT
ELECT
FILM
ELECT
ELECT
10uF
1uF
0.0033uF
1uF
1uF
20%
20%
5%
20%
20%
50V
50V
50V
50V
50V
C223
C225
C226
C240
C251
1-136-171-00
1-126-960-11
1-128-551-11
1-126-960-11
1-126-933-11
FILM
ELECT
ELECT
ELECT
ELECT
0.33uF
1uF
22uF
1uF
100uF
5%
20%
20%
20%
20%
50V
50V
25V
50V
16V
C252
C253
C254
C256
C257
1-126-964-11
1-137-367-11
1-136-157-00
1-126-960-11
1-126-960-11
ELECT
FILM
FILM
ELECT
ELECT
10uF
0.0033uF
0.022uF
1uF
1uF
20%
5%
5%
20%
20%
50V
50V
50V
50V
50V
< CONNECTOR >
* CN101
CN104
* CN105
* CN201
CN801
1-568-842-11
1-778-241-11
1-770-727-11
1-770-747-11
1-564-980-11
SOCKET, CONNECTOR 27P
CONNECTOR, BOARD TO BOARD 5P
CONNECTOR, BOARD TO BOARD 8P
CONNECTOR, BOARD TO BOARD 12P
PIN, CONNECTOR 4P
< DIODE >
D101
D102
D401
D402
D403
— 46 —
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
1N4148M
1N4148M
1N4148M
MAIN
Ref. No.
Part No.
Description
Remark
D801
D802
D804
D805
D806
8-719-987-63
8-719-987-63
8-719-933-54
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
D807
D808
8-719-987-63 DIODE 1N4148M
8-719-987-63 DIODE 1N4148M
1N4148M
1N4148M
HZS9A2L
1N4148M
1N4148M
< IC >
IC103
IC201
IC251
IC401
IC403
8-759-634-51
8-759-443-67
8-759-443-67
8-759-634-51
8-759-634-51
IC
IC
IC
IC
IC
M5218AP
LC75373ED
LC75373ED
M5218AP
M5218AP
IC901
IC903
8-759-701-59 IC NJM78M09FA
8-759-605-01 IC M5F78M18L
< JACK >
J101
J102
J103
J801
1-766-851-11 JACK, PIN 4P (1 IN OUT)
1-766-851-11 JACK, PIN 4P (2 IN OUT)
1-774-136-11 CONNECTOR, ROUND TYPE 6P
(REAR SPEAKER OUT)
1-566-819-41 JACK 1P (CONTROL S TV IN)(US,CND)
< TRANSISTOR >
Q401
Q421
Q422
Q431
Q441
8-729-141-30
8-729-141-30
8-729-900-63
8-729-141-30
8-729-141-30
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
2SC3623A-LK
DTA124ES
2SC3623A-LK
2SC3623A-LK
Q442
Q451
Q452
Q461
Q462
8-729-900-63
8-729-141-30
8-729-900-63
8-729-141-30
8-729-900-63
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124ES
2SC3623A-LK
DTA124ES
2SC3623A-LK
DTA124ES
Q803
Q804
8-729-111-29 TRANSISTOR 2SD1616A-K
8-729-116-57 TRANSISTOR 2SB1068-K
< RESISTOR >
R101
R102
R103
R104
R117
1-249-417-11
1-249-417-11
1-249-437-11
1-249-437-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
47K
47K
680
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W F
R118
R119
R120
R121
R122
1-249-441-11
1-249-415-11
1-249-441-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
680
100K
100K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W F
R123
R124
R125
R126
R127
1-249-441-11
1-249-417-11
1-249-441-11
1-247-815-91
1-247-815-91
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
100K
220
220
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R151
R152
R153
R154
1-249-417-11
1-249-417-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
1K
1K
47K
47K
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
R201
1-247-843-11 CARBON
3.3K
5%
1/4W
R202
R203
R205
R231
R232
1-249-437-11
1-249-437-11
1-249-425-11
1-249-427-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
4.7K
6.8K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R233
R281
R282
R283
R284
1-249-441-11
1-249-431-11
1-247-876-11
1-247-883-00
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
15K
75K
150K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R287
R288
R291
R292
R293
1-247-876-11
1-249-431-11
1-247-863-91
1-247-863-91
1-247-889-00
CARBON
CARBON
CARBON
CARBON
CARBON
75K
15K
22K
22K
270K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R294
R295
! R297
R407
R408
1-247-889-00
1-247-889-00
1-249-474-11
1-249-441-11
1-249-401-11
CARBON
CARBON
CARBON
CARBON
CARBON
270K
270K
1
100K
47
5%
5%
5%
5%
5%
1/4W
1/4W
1/2W
1/4W
1/4W F
R409
R410
R411
R412
R413
1-249-429-11
1-249-429-91
1-249-437-11
1-249-429-91
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
47K
10K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R414
R415
R421
R422
R423
1-249-429-11
1-249-429-11
1-249-441-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100K
1K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R424
R425
R431
R432
R433
1-247-863-91
1-249-437-11
1-249-441-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
47K
100K
1K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R441
R442
R443
R444
R445
1-249-441-11
1-249-417-11
1-249-429-11
1-247-863-91
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
10K
22K
47K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R451
R452
R453
R454
R455
1-249-441-11
1-249-417-11
1-249-429-11
1-247-863-91
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
10K
22K
47K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R461
R462
R463
R464
R465
1-249-441-11
1-249-417-11
1-249-429-11
1-247-863-91
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
1K
10K
22K
47K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R801
R803
R809
R810
R811
1-249-429-11
1-249-393-11
1-247-807-31
1-249-393-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10
100
10
47K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W
R812
1-249-437-11 CARBON
47K
5%
1/4W
— 47 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
MAIN
Ref. No.
R813
R814
R815
R816
P.S
POWER FR
Part No.
Description
1-249-441-11
1-249-425-11
1-249-429-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
Remark
100K
4.7K
10K
1K
5%
5%
5%
5%
Ref. No.
Part No.
Remark
< IC >
1/4W
1/4W F
1/4W
1/4W F
IC701
IC904
8-759-111-68 IC uPC1237HA
8-759-158-62 IC TA78057S
< JACK >
< SWITCH >
S801
Description
J701
1-571-588-11 SWITCH, SLIDE (VOLUME SYNCHRO)
1-537-952-11 TERMINAL BOARD, PUSH (ANTENNA) 2P
(EXTERNAL CENTER SPEAKER)
**************************************************************
< TRANSISTOR >
A-4403-002-A P.S BOARD, COMPLETE
********************
*
Q701
Q702
Q902
Q903
Q904
< CAPACITOR >
C701
C702
C703
C704
C705
1-126-963-11
1-126-933-11
1-126-933-11
1-126-963-11
1-104-664-11
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
100uF
100uF
4.7uF
47uF
20%
20%
20%
20%
20%
50V
16V
16V
50V
25V
C901
C902
C903
C904
C905
1-136-165-00
1-136-165-00
1-117-691-11
1-117-691-11
1-136-165-00
FILM
FILM
ELECT
ELECT
FILM
0.1uF
0.1uF
8200uF
8200uF
0.1uF
5%
5%
20%
20%
5%
50V
50V
50V
50V
50V
C907
C909
C910
C911
C912
1-126-944-11
1-126-964-11
1-126-925-11
1-126-951-11
1-126-967-11
ELECT
ELECT
ELECT
ELECT
ELECT
3300uF
10uF
470uF
470uF
47uF
20%
20%
20%
20%
20%
25V
50V
10V
35V
50V
C913
C914
C920
C930
C924
1-126-964-11
1-126-967-11
1-126-968-11
1-127-539-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
47uF
100uF
1uF
10uF
20%
20%
20%
20%
20%
50V
50V
50V
25V
50V
C925
1-104-664-11 ELECT
47uF
20%
25V
1-249-429-11
1-249-417-11
1-247-863-91
1-247-863-91
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
22K
22K
33K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R711
R906
R907
R908
R909
1-249-427-11
1-247-843-11
1-249-437-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
3.3K
47K
100
100
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R910
! R912
R913
R914
R915
1-249-431-11
1-215-888-00
1-249-429-11
1-249-429-11
1-247-843-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
220
10K
10K
3.3K
5%
5%
5%
5%
5%
1/4W
2W
F
1/4W
1/4W
1/4W
1-249-431-11 CARBON
15K
5%
1/4W
R926
< RELAY >
RY901
1-515-840-11 RELAY
< SWITCH >
S701
1-762-405-11 SWITCH, PUSH (CENTER SPEAKER)
< CORD >
< DIODE >
8-719-062-39
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
D4SBL20UF1
11ES2
11ES2
11ES2
11ES2
D907
D908
D909
D910
D911
8-719-200-82
8-719-200-82
8-719-002-43
8-719-014-66
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
UZL-27L-TA
UZP-5.6B
1N4148M
D912
D913
D914
D915
8-719-987-63
8-719-200-82
8-719-933-41
8-719-987-63
DIODE
DIODE
DIODE
DIODE
1N4148M
11ES2
HZS6C3L
1N4148M
2SC2785-FEK
DTA124ES
2SB1068-K
2SA1175-HFE
2SA1175-HFE
R706
R707
R708
R709
R710
1-778-240-11 CONNECTOR, BOARD TO BOARD 5P
1-770-723-11 CONNECTOR, BOARD TO BOARD 8P
1-564-243-11 PIN, CONNECTOR 6P
D901
D902
D903
D904
D905
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
< RESISTOR >
< CONNECTOR >
CN154
* CN155
* CN701
8-729-119-79
8-729-900-63
8-729-116-57
8-729-119-76
8-729-119-76
SDN701 1-782-492-11 CORD (WITH CONNECTOR)
(R-ch SPEAKER OUTPUT)
**************************************************************
A-4403-007-A POWER FR BOARD, COMPLETE
*************************
*
< CAPACITOR >
C601
C602
C603
C604
C605
1-126-960-11
1-162-294-31
1-104-664-11
1-162-286-21
1-136-165-00
ELECT
CERAMIC
ELECT
CERAMIC
FILM
1uF
0.001uF
47uF
220PF
0.1uF
20%
10%
20%
10%
5%
50V
50V
25V
50V
50V
C611
C612
C613
1-126-960-11 ELECT
1-162-294-31 CERAMIC
1-104-664-11 ELECT
1uF
0.001uF
47uF
20%
10%
20%
50V
50V
25V
— 48 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
POWER FR
Ref. No.
Part No.
Description
POWER SW
Remark
Ref. No.
Part No.
Description
R623
R624
! R625
R626
R627
1-249-417-11
1-249-437-11
1-217-151-00
1-247-843-11
1-249-419-11
CARBON
CARBON
METAL PLATE
CARBON
CARBON
1K
47K
0.22
3.3K
1.5K
5%
5%
10%
5%
5%
1/4W F
1/4W
2W
1/4W
1/4W F
R628
R629
R650
R651
! R691
1-249-438-11
1-249-389-11
1-249-389-11
1-249-389-11
1-212-958-00
CARBON
CARBON
CARBON
CARBON
FUSIBLE
56K
4.7
4.7
4.7
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/2W
! R692
! R693
! R694
! R695
R701
1-212-982-00
1-212-982-00
1-212-982-00
1-212-982-00
1-249-441-11
FUSIBLE
FUSIBLE
FUSIBLE
FUSIBLE
CARBON
100
100
100
100
100K
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/4W
R702
R703
R704
R705
R712
1-249-441-11
1-249-441-11
1-249-441-11
1-249-441-11
1-249-411-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
100K
100K
330
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R713
R714
1-249-411-11 CARBON
1-249-411-11 CARBON
330
330
5%
5%
1/4W
1/4W
C614
C615
1-162-286-21 CERAMIC
1-136-165-00 FILM
220PF
0.1uF
10%
5%
50V
50V
C621
C622
C623
C624
C625
1-126-960-11
1-162-294-31
1-104-664-11
1-162-286-21
1-136-165-00
ELECT
CERAMIC
ELECT
CERAMIC
FILM
1uF
0.001uF
47uF
220PF
0.1uF
20%
10%
20%
10%
5%
50V
50V
25V
50V
50V
C681
C682
C683
C684
C685
1-126-968-11
1-126-968-11
1-126-968-11
1-126-968-11
1-126-971-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
100uF
100uF
100uF
470uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C686
1-126-971-11 ELECT
470uF
20%
50V
Remark
F
F
F
F
F
F
F
F
< CONNECTOR >
CN153
* CN601
CN602
CN603
CN605
1-564-522-11
1-564-214-11
1-770-721-11
1-770-722-11
1-564-524-11
PLUG, CONNECTOR 7P
PIN, CONNECTOR (B3PS-VH) 3P
CONNECTOR, BOARD TO BOARD 4P
CONNECTOR, BOARD TO BOARD 6P
PLUG, CONNECTOR 9P
< DIODE >
D701
< RELAY >
8-719-987-63 DIODE 1N4148M
RY701
RY702
RY703
< IC >
IC601
8-749-013-55 IC STK400-030
< COIL >
L601
1-755-142-11 RELAY
1-755-142-11 RELAY
1-755-142-11 RELAY
**************************************************************
1-420-872-00 COIL, AIR-CORE
A-4403-008-A POWER SW BOARD, COMPLETE
**************************
*
< TRANSISTOR >
< CAPACITOR >
Q601
Q602
Q603
8-729-140-82 TRANSISTOR 2SA988-PAFAEA
8-729-140-82 TRANSISTOR 2SA988-PAFAEA
8-729-140-82 TRANSISTOR 2SA988-PAFAEA
< RESISTOR >
R601
R602
R603
R604
! R605
1-249-417-11
1-249-437-11
1-249-419-11
1-249-437-11
1-217-151-00
CARBON
CARBON
CARBON
CARBON
METAL PLATE
1K
47K
1.5K
47K
0.22
5%
5%
5%
5%
10%
1/4W F
1/4W
1/4W F
1/4W
2W
R606
R607
R608
R609
R611
1-247-843-11
1-249-419-11
1-249-438-11
1-249-389-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
1.5K
56K
4.7
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W F
R612
R613
R614
! R615
R616
1-249-437-11
1-249-419-11
1-249-437-11
1-217-151-00
1-247-843-11
CARBON
CARBON
CARBON
METAL PLATE
CARBON
47K
1.5K
47K
0.22
3.3K
5%
5%
5%
10%
5%
1/4W
1/4W F
1/4W
2W
1/4W
R617
R618
R619
R621
R622
1-249-419-11
1-249-438-11
1-249-389-11
1-249-417-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
56K
4.7
1K
47K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
C631
C632
C633
C634
C635
1-126-960-11
1-162-294-31
1-104-664-11
1-162-286-21
1-136-165-00
ELECT
CERAMIC
ELECT
CERAMIC
FILM
1uF
0.001uF
47uF
220PF
0.1uF
20%
10%
20%
10%
5%
50V
50V
25V
50V
50V
C642
C643
C644
C645
C687
1-162-294-31
1-104-664-11
1-162-286-21
1-136-165-00
1-126-968-11
CERAMIC
ELECT
CERAMIC
FILM
ELECT
0.001uF
47uF
220PF
0.1uF
100uF
10%
20%
10%
5%
20%
50V
25V
50V
50V
50V
C688
C689
C690
1-126-968-11 ELECT
1-126-971-11 ELECT
1-126-971-11 ELECT
100uF
470uF
470uF
20%
20%
20%
50V
50V
50V
< CONNECTOR >
CN652
CN653
1-770-725-11 CONNECTOR, BOARD TO BOARD 4P
1-770-726-11 CONNECTOR, BOARD TO BOARD 6P
< IC >
IC602
8-749-922-89 IC STK401-030
< TRANSISTOR >
Q604
Q605
— 49 —
8-729-140-82 TRANSISTOR 2SA988-PAFAEA
8-729-140-82 TRANSISTOR 2SA988-PAFAEA
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
POWER SW
Ref. No.
Part No.
RECEIVER
Description
Remark
< RESISTOR >
Ref. No.
Part No.
Description
Remark
C138
1-162-306-11 CERAMIC
0.01uF
20%
16V
R631
R632
R633
R634
! R635
1-249-417-11
1-249-437-11
1-249-419-11
1-249-437-11
1-217-151-00
CARBON
CARBON
CARBON
CARBON
METAL PLATE
1K
47K
1.5K
47K
0.22
5%
5%
5%
5%
10%
1/4W F
1/4W
1/4W F
1/4W
2W
C139
C140
C141
C143
C144
1-162-306-11
1-162-306-11
1-162-306-11
1-126-960-11
1-126-964-11
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT
0.01uF
0.01uF
0.01uF
1uF
10uF
20%
20%
20%
20%
20%
16V
16V
16V
50V
50V
R636
R637
R638
R639
R641
1-249-419-11
1-247-843-11
1-249-438-11
1-249-389-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
3.3K
56K
4.7
1K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
C145
C148
1-126-963-11 ELECT
1-162-306-11 CERAMIC
4.7uF
0.01uF
20%
20%
50V
16V
R642
R643
R644
! R645
R646
1-249-437-11
1-249-419-11
1-249-437-11
1-217-151-00
1-249-419-11
CARBON
CARBON
CARBON
METAL PLATE
CARBON
47K
1.5K
47K
0.22
1.5K
5%
5%
5%
10%
5%
1/4W
1/4W F
1/4W
2W
1/4W F
R647
R648
R649
! R696
! R697
1-247-843-11
1-249-438-11
1-249-389-11
1-212-958-00
1-212-982-00
CARBON
CARBON
CARBON
FUSIBLE
FUSIBLE
3.3K
56K
4.7
10
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/2W F
1/2W F
! R698
1-212-982-00 FUSIBLE
100
5%
1/2W F
< DIODE >
D1
D108
D109
8-719-992-09 PHOTO DIODE PP-801
8-719-001-18 DIODE UZL-9M3
8-719-313-40 DIODE SEL1516W
< IC >
IC103
IC104
IC105
8-759-602-01 IC M5220P
8-759-812-35 IC LA1235
8-759-384-90 IC TK10691MTL
< IFT >
IFT103
IFT104
1-416-229-11 COIL (DISCRIMINATOR)
1-416-200-11 COIL (FILTER)
< COIL >
**************************************************************
L1
L101
A-4398-847-A RECEIVER BOARD, COMPLETE
*************************
*
1-410-363-11 INDUCTOR
1-410-521-11 INDUCTOR
27uH
100uH
< TRANSISTOR >
< CAPACITOR >
C1
C2
C3
C4
C5
1-162-306-11
1-162-306-11
1-136-177-00
1-162-306-11
1-162-306-11
CERAMIC
CERAMIC
FILM
CERAMIC
CERAMIC
0.01uF
0.01uF
1uF
0.01uF
0.01uF
20%
20%
5%
20%
20%
16V
16V
50V
16V
16V
Q1
Q2
Q3
Q4
Q102
8-729-218-43
8-729-119-76
8-729-119-78
8-729-119-76
8-729-209-15
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK184-GR
2SA1175-HFE
2SC2785-HFE
2SA1175-HFE
2SD2012
C6
C101
C102
C103
C104
1-102-962-00
1-162-306-11
1-104-664-11
1-126-960-11
1-102-973-00
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
30PF
0.01uF
47uF
1uF
100PF
5%
20%
20%
20%
5%
50V
16V
25V
50V
50V
Q105
Q106
Q107
8-729-119-78 TRANSISTOR 2SC2785-HFE
8-729-029-66 TRANSISTOR DTC114ESA
8-729-029-66 TRANSISTOR DTC114ESA
C105
C106
C107
C108
C109
1-110-335-11
1-126-960-11
1-137-364-11
1-130-467-00
1-110-335-11
MYLAR
ELECT
CERAMIC
MYLAR
MYLAR
100PF
1uF
0.001uF
470PF
100PF
5%
20%
5%
5%
5%
50V
50V
50V
50V
50V
R1
R2
R3
R4
R5
1-249-421-11
1-249-417-11
1-249-411-11
1-249-421-11
1-249-438-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
1K
330
2.2K
56K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
1/4W
C110
C113
C126
C127
C128
1-102-973-00
1-126-960-11
1-126-933-11
1-104-664-11
1-162-306-11
CERAMIC
ELECT
ELECT
ELECT
CERAMIC
100PF
1uF
100uF
47uF
0.01uF
20%
20%
20%
20%
20%
16V
50V
16V
25V
16V
R6
R7
R8
R101
R102
1-249-441-11
1-247-843-11
1-249-417-11
1-249-425-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
3.3K
1K
4.7K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
C129
C130
C131
C132
C133
1-104-664-11
1-104-664-11
1-126-956-91
1-162-306-11
1-162-306-11
ELECT
ELECT
ELECT
CERAMIC
CERAMIC
47uF
47uF
0.1uF
0.01uF
0.01uF
20%
20%
20%
20%
20%
25V
25V
50V
16V
16V
R103
R104
R105
R106
R107
1-247-863-91
1-249-425-11
1-249-417-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
4.7K
1K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W F
C134
C135
C136
C137
1-126-963-11
1-162-306-11
1-104-666-11
1-162-306-11
ELECT
CERAMIC
ELECT
CERAMIC
4.7uF
0.01uF
220uF
0.01uF
20%
20%
20%
20%
50V
16V
25V
16V
R108
R115
R119
R127
1-249-429-11
1-249-409-11
1-249-437-11
1-249-409-11
CARBON
CARBON
CARBON
CARBON
10K
220
47K
220
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
< RESISTOR >
— 50 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
RECEIVER
Ref. No.
R128
Part No.
Description
Remark
1-249-441-11 CARBON
100K
5%
1/4W
! R129
R130
R131
R132
R136
1-249-409-11
1-249-425-11
1-249-431-11
1-247-843-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
220
4.7K
15K
3.3K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
R191
R192
R193
R195
1-249-417-11
1-249-411-11
1-249-411-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
1K
330
330
100
5%
5%
5%
5%
1/4W F
1/4W F
1/4W F
1/4W
Ref. No.
T1
Part No.
T2
TRANSMITTER
Description
Remark
< FUSE HOLDER >
FH903
FH904
FH905
FH906
1-533-217-31
1-533-217-31
1-533-217-31
1-533-217-31
HOLDER, FUSE
HOLDER, FUSE
HOLDER, FUSE
HOLDER, FUSE
< RESISTOR >
! R901
! R902
1-212-950-00 FUSIBLE
1-212-934-00 FUSIBLE
4.7
1
5%
5%
1/2W F
1/2W F
**************************************************************
< VARIABLE RESISTOR >
A-4403-191-A TRANSMITTER BOARD, COMPLETE
****************************
*
RV102
1-238-600-11 RES, ADJ, CARBON 10K
< CAPACITOR >
< TEST PIN >
* TP102
1-565-513-11 PIN, CONNECTOR 2P
**************************************************************
1-666-219-11 T1 BOARD
********
*
< CAPACITOR >
!C915
1-113-925-11 CERAMIC
0.01uF
20%
250V
C201
C202
C203
C204
C205
1-126-960-11
1-162-294-31
1-162-282-31
1-102-508-91
1-162-282-31
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1uF
1000PF
100PF
10PF
100PF
20%
10%
10%
0.5PF
10%
50V
50V
50V
50V
50V
C206
C207
C208
C209
C210
1-126-964-11
1-104-664-11
1-126-963-11
1-126-960-11
1-164-159-21
ELECT
ELECT
ELECT
ELECT
CERAMIC
10uF
47uF
4.7uF
1uF
0.1uF
20%
20%
20%
20%
50V
25V
50V
50V
50V
C211
C212
C213
C214
C216
1-104-664-11
1-126-960-11
1-126-933-11
1-164-159-21
1-104-664-11
ELECT
ELECT
ELECT
CERAMIC
ELECT
47uF
1uF
100uF
0.1uF
47uF
20%
20%
20%
25V
50V
16V
50V
25V
C217
C218
C220
C221
C222
1-102-121-00
1-102-508-91
1-102-121-00
1-164-159-21
1-104-664-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
2200PF
10PF
2200PF
0.1uF
47uF
10%
0.5PF
10%
C223
C225
C227
C228
C291
1-164-159-21
1-102-121-00
1-104-663-11
1-164-159-21
1-104-663-11
CERAMIC
CERAMIC
ELECT
CERAMIC
ELECT
0.1uF
2200PF
33uF
0.1uF
33uF
C292
C294
C295
C296
1-126-960-11
1-104-663-11
1-126-924-11
1-164-159-21
ELECT
ELECT
ELECT
CERAMIC
1uF
33uF
330uF
0.1uF
< CONNECTOR >
CN901
1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
< FUSE >
! F901
! F901
1-532-503-51 FUSE TIME-LAG (T1.6AL/250V)
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-576-108-11 FUSE (4A/125V)(US,CND)
< FUSE HOLDER >
FH901
FH902
1-533-217-31 HOLDER, FUSE
1-533-217-31 HOLDER, FUSE
< TRANSFORMER >
! T901
! T901
1-431-429-11 TRANSFORMER, POWER (US,CND)
1-431-438-11 TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
**************************************************************
1-666-220-11 T2 BOARD
********
*
20%
10%
20%
20%
20%
20%
20%
50V
50V
50V
50V
25V
50V
50V
25V
50V
25V
50V
25V
6.3V
50V
< CONNECTOR >
* CN201
CN211
< CONNECTOR >
CN904
20%
1-506-989-11 PIN, CONNECTOR (PC BOARD) 7P
1-506-468-11 PIN, CONNECTOR 3P
1-564-511-11 PLUG CONNECTOR 8P
< DIODE >
< FUSE >
! F902
! F902
! F903
! F903
1-532-504-51 FUSE TIME-LAG (T4AL/250V)
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-576-110-11 FUSE (6A/125V)(US,CND)
1-532-504-51 FUSE TIME-LAG (T4AL/250V)
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
1-576-110-11 FUSE (6A/125V)(US,CND)
D201
D291
8-719-057-93 DIODE SVC203SPA-AL
8-719-987-63 DIODE 1N4148M
< IC >
IC202
IC203
— 51 —
8-759-634-50 IC M5218AL
8-759-384-88 IC TK10690MTL
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
SAVA-57
TRANSMITTER
Ref. No.
IC291
IC292
Part No.
Description
Remark
8-759-165-80 IC PST600C-T
8-759-708-08 IC NJM78L08A
< COIL >
L201
L203
1-416-171-11 COIL (OSC)
1-410-521-11 INDUCTOR
100uH
< TRANSISTOR >
Q201
Q202
Q203
Q291
Q292
8-729-266-83
8-729-266-83
8-729-119-76
8-729-801-84
8-729-029-20
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2668-Y
2SC2668-Y
2SA1175-HFE
2SB1013-4
RT1P141SK-TP
Q294
8-729-029-66 TRANSISTOR DTC114ESA
< RESISTOR >
R201
R202
R203
R204
R205
1-249-417-11
1-249-441-11
1-249-421-11
1-247-863-91
1-249-419-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
2.2K
22K
1.5K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W
R206
R207
R208
R209
R211
1-249-431-11
1-249-418-11
1-247-862-11
1-247-862-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
1.2K
20K
20K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W F
R212
R213
R214
R215
R216
1-215-445-00
1-247-843-11
1-247-854-11
1-247-893-11
1-249-417-11
METAL
CARBON
CARBON
CARBON
CARBON
10K
3.3K
9.1K
390K
1K
1%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R218
R219
R220
R222
R225
1-249-413-11
1-249-441-11
1-249-441-11
1-249-417-11
1-215-461-00
CARBON
CARBON
CARBON
CARBON
METAL
470
100K
100K
1K
47K
5%
5%
5%
5%
1%
1/4W F
1/4W
1/4W
1/4W F
1/4W
R226
R227
R291
R292
R293
1-215-431-00
1-249-421-11
1-215-445-00
1-215-432-00
1-215-445-00
METAL
CARBON
METAL
METAL
METAL
2.7K
2.2K
10K
3K
10K
1%
5%
1%
1%
1%
1/4W
1/4W F
1/4W
1/4W
1/4W
R294
R296
1-247-807-31 CARBON
1-247-863-91 CARBON
100
22K
5%
5%
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
111
205
! 261
! 261
1-773-274-11
1-775-758-11
1-782-510-11
1-782-603-11
WIRE (FLAT TYPE) (27 CORE)
LEAD (WITH CONNECTOR)
CORD, POWER (CH)
CORD, POWER (AEP,UK,G,E,SP,MY,TH,AUS,CH)
! 261
! 264
CNP201
FL501
SP301
1-782-604-11
1-770-019-11
1-782-270-11
1-517-673-11
1-505-643-11
CORD, POWER (US,CND)
ADAPTOR, CONVERSION PLUG 3P (UK)
CORD, CONNECTION (TRANSMITTER 3.5m)
INDICATOR TUBE, FLUORESCENT
SPEAKER (10cm)
SP302
SP901
SP902
SP903
SP904
1-505-643-11
1-505-654-11
1-505-655-11
1-505-656-11
1-505-657-11
SPEAKER (10cm)
SPEAKER (5cm)
SPEAKER (10cm)
SPEAKER (12cm)
SPEAKER (16cm)
SP905
SP906
SP907
SP908
! T301
1-505-654-11
1-505-655-11
1-505-656-11
1-505-657-11
1-431-342-11
SPEAKER (5cm)
SPEAKER (10cm)
SPEAKER (12cm)
SPEAKER (16cm)
TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
! T301
! T901
! T901
1-431-343-11 TRANSFORMER, POWER (US,CND)
1-431-429-11 TRANSFORMER, POWER (US,CND)
1-431-438-11 TRANSFORMER, POWER
(AEP,UK,G,E,SP,MY,TH,AUS,CH)
**************************************************************
ACCESSORIES & PACKING MATERIALS
*******************************
1-475-042-11
1-475-232-11
1-558-787-81
1-769-433-11
1-775-531-11
ADAPTOR (SCART) (AEP,UK,G)
REMOTE COMMANDER (RM-J57)
CORD, CONNECTION (AUDIO 1.5m)
CORD, SPEAKER (REAR SPEAKER)
CORD, CONNECTION
(FRONT L-R CONNECTION 3.5m)
3-860-299-11 MANUAL, INSTRUCTION (ENGLISH)
3-860-299-21 MANUAL, INSTRUCTION (FRENCH,SPANISH)
(CND,AEP,E,SP)
3-860-299-31 MANUAL, INSTRUCTION
(GERMAN,DUTCH,ITALIAN,SWEDISH,PORTUGUESE) (AEP,G)
3-860-299-41 MANUAL, INSTRUCTION (CHINESE)(E,SP,MY,CH)
4-983-536-01 COVER, BATTERY (for RM-J57)
**************************************************************
*************
HARDWARE LIST
*************
< THERMISTOR >
TH201
1-807-972-11 THERMISTOR
**************************************************************
MISCELLANEOUS
*************
10
68
! 110
! 110
! 110
1-782-666-11
1-782-666-11
1-575-042-21
1-575-651-21
1-751-529-11
CORD
CORD
CORD, POWER (US,CND)
CORD, POWER (AEP,G,E,SP,MY,TH,AUS)
CORD, POWER (UK)
! 110
1-782-510-11 CORD, POWER (CH)
#1
#2
#3
#4
#5
7-621-846-60
7-685-134-19
7-685-646-79
7-685-881-09
7-685-650-79
#6
#7
#8
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT
7-685-661-79 SCREW +P 4X12 TYPE2 NON-SLIT
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Sony Corporation
9-920-944-11
SCREW (4X25), TAPPING
SCREW +2.6X8 TYPE2 SLIT
SCREW +BVTP 3X8 TYPE2 N-S
SCREW +BVTT 4X8 (S)
SCREW +BVTP 3X16 TYPE2 N-S
Home A&V Products Company
— 52 —
Les composants identifiés par
une marque ! sont critiques pour
la sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
97G0995-1
Printed in Japan © 1997. 7
Published by General Engineering Dept.
(Shibaura)