Download SERVICE MANUAL - Wiki Karat

SA-WMS25
SERVICE MANUAL
AEP Model
UK Model
E Model
Ver 1.0 2002. 09
• SA-WMS25 is the subwoofer section in
HT-K25.
SPECIFICATION
POWER OUTPUT
Rated Power Output at Stereo mode
(6 ohms 1 kHz, THD 0.7 %)
40 W + 40 W
Reference Power Output
(THD 0.7 %)
Front*: 40 W/ch
Center*: 40 W
Surround*: 40 W/ch
(6 ohms)
Subwoofer: 70 W
(3 ohms)
* Depending on the sound field settings and the
source, there may be no sound output.
Frequency response
General
Power requirements
Area code
Power requirements
CEL, CEK, SP
220–230 V AC, 50/60 Hz
MX
120 V AC, 60 Hz
Power consumption
Power consumption (during standby mode)
0.8 W
Dimensions (w/h/d)
20 Hz – 20 kHz
Mass (Approx.)
Enclosure type
Speaker unit
Advanced S.A.W.
magnetically shielded
68 W
224 × 318.5 × 344 mm
including front panel
7.1 kg
Design and specifications are subject to change
without notice.
16 cm cone type
NOTE:
Rated frequency range
30 Hz – 200 Hz
High frequency cut-off frequency
150 Hz
·
is the specifications when connecting TA-VE25.
· Abbreviation
CEK : UK model
CEL : AEP model
MX : Mexican model
SUBWOOFER
9-874-149-01
Sony Corporation
2002I1600-1
© 2002.09
Home Audio Company
Published by Sony Engineering Corporation
SA-WMS25
TABLE OF CONTENTS
1. DISASSEMBLY
1-1. DSP Board ····································································· 3
1-2. PS Board ········································································ 4
1-3. DIGITAL AMP Board ··················································· 4
2. DIAGRAMS ································································· 5
2-1. Block Diagrams — Power Section — ·························· 6
— DSP/AMP Section — ··················· 7
2-2. Printed Wiring Boards
— DIGITAL AMP Section (Side A) — ························ 8
2-3. Printed Wiring Boards
— DIGITAL AMP Section (Side B) — ························ 9
2-4. Schematic Diagram
— DIGITAL AMP Section (1/2) — ···························· 10
2-5. Schematic Diagram
— DIGITAL AMP Section (2/2) — ···························· 11
2-6. Printed Wiring Board — PS Board (Side A) — ········· 12
2-7. Printed Wiring Board — PS Board (Side B) — ········· 13
2-8. Schematic Diagram — PS Board — ·························· 14
2-9. Printed Wiring Board — DSP Board — ···················· 15
2-10. Schematic Diagram — DSP Board (1/2) — ·············· 16
2-11. Schematic Diagram — DSP Board (2/2) — ·············· 17
2-12. IC Block Diagrams ····················································· 18
2-13. IC Pin Function Description ······································· 20
Unleaded solder
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow) than
ordinary solder so use caution not to let solder bridges occur such
as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
3. EXPLODED VIEWS
3-1. Cabinet Section ··························································· 24
3-2. AMP Section ······························································· 25
4. ELECTRICAL PARTS LIST ······································· 26
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
2
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
SA-WMS25
SECTION 1
DISASSEMBLY
• The equipment can be removed using the following procedure.
SET
DSP BOARD
PS BOARD
DIGITAL AMP BOARD
Note: Follow the disassembly procedure in the numerical order given.
1-1. DSP Board
1 four screws
(+BTP 4 × 20)
3 back panel
9 connector
(CNP601)
8 flexible flat cable
(21core)
q; DSP board
4 four screws
(+BVTP 3 × 8)
2 four screws
(+BTP 4 × 20)
7 two screws
(+BVTP 3 × 8)
6 shield plate
5 three screws
(+BVTP 3 × 8)
3
SA-WMS25
1-2. PS Board
3 PS board
1 four screws
(+BVTP 3 × 8)
2 connector
(CNP301)
1-3. DIGITAL AMP Board
7 DIGITAL AMP board
6 three screws
(+BVTP 3 × 8)
3 back panel
2 four screws
(+BVTP 3 × 8)
4 connector
(CNP401)
1 four screws
(+BVTP 3 × 8)
5 connector
(CNP302)
4
SA-WMS25
SECTION 2
DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
Note on Printed Wiring Boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
• b : Pattern from the side which enables seeing.
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. p: pF. 50
WV or less are not indicated except for electrolytics and
tantalums.
• 2 : nonflammable resistor
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
• C : panel designation
f
•
: internal component
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
• A : B+ Line
• B : B– Line
• Voltages are dc with respect to ground under no-signal
conditions.
no mark : Power on
• Voltages are taken with a VOM (Input impedance 10MΩ).
Voltage variations may be noted due to normal preduction
tolerances.
• Signal path.
F : ANALOG INPUT
c : DIGITAL INPUT
• Abbreviation
MX : Mexican model
• Waveforms
2 IC501 id (X1)
1 IC300 4
20.3ns
6.5Vp-p
200ns
2V/DIV, 10ns/DIV
1V/DIV, 100ns/DIV
3 IC605 qs (MCLK2)
4 IC606 wa (XOUT)
73.5ns
1V/DIV, 40ns/DIV
4.1Vp-p
81.5ns
3.9Vp-p
4.8Vp-p
1V/DIV, 40ns/DIV
5
SA-WMS25
2-1. Block Diagrams — Power Section —
+28V
IC903
+12V
2
+12V
REG
1
5
D303
POWER
D302
D301
+5V
2
+6.2V
IC908
+3.3V
3
D911
+6.2V
1
REG
RECT
T901
5
Q906, 908
+3.3V
1
REG
IC907
LF901,902
D903
F901
SWITCH
LINE
FILTER
D919
D916
AC
IN
IC905
+5.6V
3
+5.6V
1
REG
D920
IC901
SWITCHING REG
3 D
IC906
+3.3V
FOR
FLASH
PROGRAMMING
3
Q902, D905
+3.3V
1
REG
IC904
VCC
D906
Q905
REG
REG
4 VCC
1 OCP/SYNC
2 GND
PC901
PWCNT2 75
ERROR
1
2
AMP
IC904
D/AOUT 63
VCONT
5 FB/OLP
IC902
PWCONT2
3
Q913, 915
1
BUFFER
2
IC501 (2/2)
SYSTEM CONTROL
Q901, 903
PWCNT1 76
PWCONT1
SWITCH
PC902
IC910
STOP 52
CNP602 (2/2)
TO
TA-VE25
6
CONTROL
STOP
STOP
8 RESET
7
6
+5.6V
SA-WMS25
— DSP/AMP Section —
CNP602 (1/2)
LCH+
3
LCH-
2
RCH+
5
RCH-
6
IC601 (1/2)
1
IC601 (2/2)
7
IC602
5 1
3
D.SIG
IC605
AUDIO DSP
1 LIN
5 RIN
7
5 DIN2
DO
16 SYSCLK
XMCK 20
6 RSTB
35 DO
DI
DOUT 15
18 SDI1
BCK 14
17 BCKI1
LRCK 13
15 LRCKI1
IC305
STREAM PROCESSOR
DT FL/FR
SDO1 23
38 CLK
CE
22 XIN
X602
12.288MHz
BCK 14
29 BCKI2
LRCK 15
28 LRCKI2
OUTL2+ 15
16 INB
BCKO
44 BCK
LRCKO
69 GP8
59 EXLOCK
Q501
41 INIT
BCKO 20
48 XMODE
9 MCLK1
X601
13.5MHz
OUTR1+ 10
6 INA
OUTR2+ 1
16 INB
39 NSPMUTE
LRCKO 19
7 ENA
40 PGMUTE
L
2
4
28 XFS0IN
XFS0OUT 77
SRAM
OUTA 9
L402,C403
LPF
OUTB 19
L401,C404
LPF
Q402,
DC DETECT
Q412
8 DIAGA
18 DIAGB
74 FS0I
D0-15 105 77
.
102
. 75
FS0CKO 73
X301
49.152MHz
99 72
12 MCLK2
IC308
112
. 82
.
110
. 85
BUSY(MAIN)
33 HDIN
34 HCLK
36 HCS
113 PM
56 BST
COM(SUB)
2 XRST
STREAM PROCESSOR
A0-15 109 83
. .
97 66
43 DATA
D605
6 INA
OUTL2+ 15
16 INB
7 ENA
44 BCK
WE0 45
L403,C405
LPF
OUTB 19
L403,C406
LPF
CENTER
SPEAKER OUT
Q403,
DC DETECT
Q413
8 DIAGA
38 SCDT
GP9 68
J401 (2/3)
OUTA 9
17 ENB
45 LRCK
CS0 44
IC306
POWER DRIVER (C)
OUTL1+ 24
64 XFS1IN
92 64
18 DIAGB
37 SCSHIFT
HACN 32
36 SCLATCH
HDOUT 35
IC307
POWER DRIVER (W)
OUTA 9
L404,C407
LPF
OUTB 19
L404,C408
LPF
41 INIT
COM(MAIN)
REAR
17 ENB
IC300
IC603
108
. 98
.
107
. 80
FRONT
Q401,
DC DETECT
Q411
IC304
POWER DRIVER (FR)
37 SCSHIFT
GP10 67
XSTATE 17
47 CLKSEL1
L401,C402
LPF
18 DIAGB
36 SCLATCH
AUDIO 24
OUTB 19
45 LRCK
22 KFSIO
ERROR 34
L401,C401
LPF
8 DIAGA
38 SCDT
21 XOUT CKOUT 13
J401 (1/3)
OUTA 9
17 ENB
64 XFS1IN
SCKOUT 14
Q502
6 INA
7 ENA
SCK
30 SDI2
IC301
POWER DRIVER (FL)
OUTL1+ 24
DT SL/SR
SDO2 24
DATAO 16
37 CE
CONTROL
43 DATA
DT C/SW
SDO3 25
36 DI
CLK
D601
39 NSPMUTE
OUTR1+ 10
6 INA
40 PGMUTE
OUTR2+ 1
16 INB
7 ENA
28 XFS0IN
Q503
XFS0OUT 77
(WOOFER)
17 ENB
Q404,
Q414 DC DETECT
8 DIAGA
74 FS0I
18 DIAGB
IC318
STREAM PROCESSOR
43 DATA
Q504
6 INA
OUTL2+ 15
16 INB
7 ENA
DI
DO
4
2
1
99 98 100
7
19 20 89 92 88 91
18
90
87
RSTX
DO
DI
CLK
CE
CLKSEL1
XMODE
XSTATE
ERROR
PD
HDIN
HDOUT
HACN
GP9
PM
3
BST
5
XRST
6
HCS
77
HCLK
55
DATAO
30
SSHIFT 60
RST 64
NSPMUTE 61
IC501 (1/2)
SYSTEM CONTROL
PGMUTE 62
EN 66
DIAG 54
FRONT
IC311
POWER DRIVER (RR)
SCDT
SHIFT
41 INIT
LAT1
39 NSPMUTE
OUTR1+ 10
6 INA
40 PGMUTE
OUTR2+ 1
16 INB
LAT2
LAT3
7 ENA
28 XFS0IN
RST(INIT)
NSMUTE
74 FS0I
PGMUTE
R
OUTA 9
L406,C412
LPF
REAR
OUTB 19
L406,C413
LPF
17 ENB
8 DIAGA
Q406,
DC DETECT
Q416
18 DIAGB
EN
Q328
DIAG
SWITCH
51 MD2
• Signal Path
82
X1
MD2
J401 (3/3)
Q405,
DC DETECT
Q415
49 MD0
X0
MD0
L405,C410
LPF
18 DIAGB
36 SCLATCH
SDATA 59
AMPCE3 58
28 COMOUT
27 COMIN
OUTB 19
37 SCSHIFT
AMPCE2 57
FLASH2
L405,C409
LPF
8 DIAGA
38 SCDT
AMPCE1 56
FLASH1
OUTA 9
17 ENB
45 LRCK
BUSYIN
RESET
CLK
CE
44 BCK
CNP501
FLASH
PROGRAMMING
IC309
POWER DRIVER (RL)
OUTL1+ 24
64 XFS1IN
BUSYOUT
TO
TA-VE25
IC604
AUDIO
A/D CONV
IC606
DIGITAL AUDIO
I/F RECEIVER
IC607
83
+2.6V
3
1
REG
+2.6V
: ANALOG INPUT
5V
: DIGITAL INPUT
X501
5MHz
7
7
SA-WMS25
2-2.
Printed Wiring Board — DIGITAL AMP Section (Side A) — •
: Uses unleaded solder.
IC300
• Semiconductor
Location
Ref. No.
IC305
IC308
(Page 15)
IC318
8
8
Location
D331
D332
D333
D334
D335
D336
D341
D342
D343
D344
D345
D346
D361
D362
D363
D364
D365
D366
A-2
B-2
B-2
C-2
D-2
D-2
A-4
B-4
C-4
C-4
D-4
E-4
A-3
B-3
C-3
D-3
D-3
E-3
IC300
IC305
IC308
IC318
A-1
B-1
C-1
D-1
Q328
C-5
SA-WMS25
2-3.
Printed Wiring Boards — DIGITAL AMP Section (Side B) — •
: Uses unleaded solder.
• Semiconductor
Location
Ref. No.
IC301
IC304
IC306
IC307
IC309
IC311
(Page 13)
(Page 13)
9
9
Location
D301
D302
D311
D312
D313
D314
D315
D316
D321
D322
D323
D324
D325
D326
D351
D352
D353
D354
D355
D356
D401
D402
D403
D404
D405
D406
E-1
E-1
A-3
B-3
B-3
C-3
D-3
D-3
A-3
B-3
C-3
C-3
D-3
E-3
A-5
B-5
C-5
C-5
D-5
E-5
A-1
B-1
B-1
C-1
A-1
C-1
IC301
IC304
IC306
IC307
IC309
IC311
A-4
B-4
C-4
C-4
D-4
E-4
Q401
Q402
Q403
Q404
Q405
Q406
Q411
Q412
Q413
Q414
Q415
Q416
A-1
B-1
B-1
D-1
A-1
C-1
A-1
B-1
B-1
D-1
A-1
C-1
SA-WMS25
Schematic Diagram — DIGITAL AMP Section (1/2) — • See page 18 for IC Block Diagrams.
CNP303
2P
CNP301
8P
D303
SEL5723C
CNP302
2P
R370
680
R302
1M
C307
5p
C311
0.01
C432
10p
D301
11ES2-TB5
D302
11EQS04-TB5
0.01
C306
0.01
X301
49.152MHz
C308
1000p
L302
C380
470p
C302
C301
100
10V
R301
220
C309
2200
35V
0UH
IC300
MC74VHC1GU04DFT1
FB300
IC301
CXD9702L
C312
100 10V
CNS301
21P
1k
R336
1k
R338
1k
R339
100
R340
100
R341
100
R342
100
R344
100
C319
0.1
C318
100
10V
C305
0.1
D331
P6SMB36AT3
0.022
C310
100
10V
C416
0.1
C417
0.1
IC304
CXD9702L
R307
100
C344
0.01
D312
LI116
L402
C351
0.01
1k
C342
100
35V
C345
100
10V
C343
0.1
0.1
C420
0.1
C404
1
50V
C341
0.1
C333
0.1 B
D322
LI116
R320
100
C421
D342
P6SMB36AT3
R322
100
C403
1
50V
C314
C315
0.1 100 10V
D401
R401
220k
C385
470p
R325
22
C359
0.01
R346
C415
0.1
IC305
CXD9730Q
C372
0.01
R347
10k
C414
0.1
C402
1
50V
D341
P6SMB36AT3
C331
0.01
R334
D321
LI116
C317
100
35V
C401
1
50V
D332
P6SMB36AT3
100
C333
0.022
100
R319
D362
SFPL-62V
R318
C316
0.1
C313
0.1 B
0.022
100
C334
100
R317
J401
L401
D352
SFPL-62V
R316
C328
0.01
100
100
R305
R315
D311
LI116
C304
R304
100
D361
SFPL-62V
FB301
0UH
D351
SFPL-62V
C326
47
16V
C327
0.01
C303
0.022
FB304
0UH
C358
0.01
2-4.
4.7
C427
10V
Q411
2SA1162
-YG-TE85L
7
7
Q401
2SA1162
-YG-TE85L
R411
220k
0
1SS355TE-17
D402
R402
220k
4.7
C428
10V
0
F
7
Q412
2SA1162
-YG-TE85L
7
Q402
2SA1162
-YG-TE85L
R412
220k
0
R407
1k
3.2
0
C434
0.1
25V
F
Q328
2SC2712-GL-TE85L
10
10
1SS355TE-17
0
F
R408
1k
SA-WMS25
Schematic Diagram — DIGITAL AMP Section (2/2) — • See page 18 for IC Block Diagrams.
IC306
CXD9702L
C349
0.01
C336
100
10V
C337
100
10V
D333
P6SMB36AT3
D353
SFPL-62V
D363
SFPL-62V
C348
0.01
C356
0.022
C354
0.022
D313
LI116
L403
FB302
0UH
C405
1
50V
C418
0.1
C419
0.1
C422
0.1
C423
0.1
C425
0.1
C426
0.1
C406
1
50V
FB305
0UH
R321
100
C353
0.1
B
D323
LI116
D343
P6SMB36AT3
C363
0.1
C377
0.01
C364
100 35V
C362
100
10V
C365
0.1
C320
0.1
C321
100
10V
IC307
CXD9702L
D403
C378
0.01
C352
0.01
R403
220k
R330
100
4.7
C429
10V
1SS355TE-17
0
F
7
Q413
2SA1162
-YG-TE85L
7
IC308
CXD9730Q
R413
220k
R333
100
C379
0.01
C376
0.022
D334
P6SMB36AT3
D354
SFPL-62V
D314
LI116
D364
SFPL-62V
0
Q403
2SA1162
-YG-TE85L
D404
C375
0.022
L404
C373
0.01
C374
0.1
C407
1
50V
C408
1
50V
R404
220k
4.7
D324
LI116
C382
0.1
C384
0.1
C322
0.1
Q404
2SA1162
-YG-TE85L
4.7
R414
220k
D405
C431
10V
1SS355TE-17
0
F
7
C323
100
10V
Q415
2SA1162
-YG-TE85L
7
Q405
2SA1162
-YG-TE85L
R406
220k
IC309
CXD9702L
C357
0.01
Q414
2SA1162
-YG-TE85L
7
R405
220k
C383
100 35V
1SS355TE-17
0
F
0
D344
P6SMB36AT3
R335
100
C381
100
10V
C430
10V
7
B
C355
0.01
TP301
R415
220k
0
D406
4.7
C433
10V
7
1SS355TE-17
0
F
Q416
2SA1162
-YG-TE85L
7
R345
1k
C391
0.01
C390
0.01
D355
SFPL-62V
FB315
0UH
C392
100
10V
C397
0.022
L405
C389
100
10V
C324
C396
0.022
C395
0.1
B
FB314
0UH
C409
1
50V
C410
1
50V
0.1
D325
LI116
D345
P6SMB36AT3
R343
100
C325
100 35V
C394
0.01
C329
100
10V
C335
100
10V
C330
0.1
C338
0.1
IC311
CXD9702L
C393
0.01
C398
0.01
C361
0.01
C370
0.022
R349
100
D316
LI116
D356
SFPL-62V
C369
0.022
L406
C339
0.1
R350
100
C399
0.01
C371
C340
100 35V
C346
100
10V
C367
0.01
C366
0.01
11
D336
P6SMB36AT3
R348
100
IC318
CXD9730Q
D366
SFPL-62V
C360
0.01
D315
LI116
Q406
2SA1162
-YG-TE85L
D335
P6SMB36AT3
C387
0.01
0.01
C386
470p
D365
SFPL-62V
0
C388
2-5.
11
C347
0.1
0.1
D326
LI116
B
C350
100
10V
C368
0.1
C412
1
50V
C413
1
50V
D346
P6SMB36AT3
R416
220k
CNP401
VHS2P
SA-WMS25
2-6.
Printed Wiring Board — PS Board (Side A) —
•
: Uses unleaded solder.
• Semiconductor
Location
Ref. No.
IC904
IC910
IC910
IC904
12
12
Location
E-3
E-5
SA-WMS25
2-7.
Printed Wiring Board — PS Board (Side B) — •
: Uses unleaded solder.
• Semiconductor
Location
IC907
IC901
(Page 9)
IC903
IC908
IC906
(Page 9)
(Page 15)
13
13
PC901
IC902
PC902
IC905
Ref. No.
Location
D902
D903
D905
D906
D907
D908
D911
D912
D913
D914
D916
D918
D919
D920
D931
D932
D933
D-5
B-4
E-3
E-4
D-5
D-4
B-3
E-4
E-2
D-2
D-1
D-1
A-4
B-4
E-4
E-4
D-5
IC901
IC902
IC903
IC905
IC906
IC907
IC908
D-5
E-4
D-2
D-2
E-3
D-1
D-1
PC901
PC902
E-5
E-5
Q901
Q902
Q903
Q905
Q906
Q908
Q913
Q915
E-4
D-3
E-5
D-4
D-1
D-1
E-4
E-4
SA-WMS25
Schematic Diagram — PS Board — • See page 19 for IC Block Diagrams.
C939
0.22
50V
C942
22
25V
C914
0.1
R928
15k
R932
2.7k
R906
10k
1/10W
R915
2.7k
R918
1k
C928
1000p
50V
R924
1k
IC905
BA05T
Q915
2SC2412K-T-146-R
R927
100k
Q902
2SC2412K-T-146-R
IC910
NJM2103M-TE2
D905
UDZS-TE-176.8B
D913
1SS355TE-17
C927
0.1
C929
100
10V
Q913
2SC2412K-T-146-R
IC904
BA10358F-T1
PC902
TLP421
R925
1k
C922
1
50V
R904
R902
C917
0.001
250V
E
C915
IC901
D932
1k
L904
L907
0
C930
0.1
C924
2200
35V
C944
100
10V
R920
2.2k
IC908
BA033T
R917
2.7k
L901
L902
C920
4700p
630V
L903
CN904
5P
CN903
4P
14
14
D911
FML-22S
R905
D920
11ES4-TB5
JR901
R919
10k
C921
6800
35V
R901
220
C908
220p
R938
150k
R912
1.5k
R911
33k/2W
47
33
C912
R908
C906
0.001
250V
C907
0.001
250V
TH901
C910
0.001
250V
C909
0.001
250V
C902
0.1
250V
C903
0.1
250V
CNP901
2P
R930
3.3M
LF902
D903
C913
R929
C926
100p
50V
D933
11EQS10-TB5
R934
33k
2W
R909
R936
R937
1k
1k
C918
0.1
R935
10k
R916
1.2k(MX)
2.2K(EXCEPT MX)
IC903
SI-8120JF
IC907
SI-8050JF
L905
IC902
SE-B2
CN905
10P
C905
0.0047
50V
UDZS-TE17-22B
D908
SARS03
D912
UDZS-TE-175.6B(EXCEPT MX)
UDZSTE-176.2B(MX)
Q901
RT1N141C-TP-1
C901
4.7
50V
D907
11EQS10-TB5
D902
11EQS10-TB5
R913
3.3
L906
Q905
2SD1616A-TP-LK
Q903
RT1N141C-TP-1
R907
L909
4.7k
C916
820
C935
1000
16V
D906
11EQS10-TB5
C934
D918
11EQS04-TB5
C933
0.1
R933
16V
T901
R931
180
C911
47
50V
D931
UDZS-TE-1720B
C931
0.1
PC901
TLP421
D914
11EQS04-TB5
C940 0.1
R926
10k
C943
100
10V
1000
Q906
RT1N141C-TP-1
Q908
RT1N141C -TP-1
1W
C938
1000p
50V
R914
2.7k
IC906
BA033T
C936
0.001
250V
R903
0.12
C932
0.1
D919
11ES4-TB5
R923
47k
JR902
C925
0.01
D916
11EQS04-TB5
2-8.
LF901
F901
SA-WMS25
2-9.
Printed Wiring Board — DSP Board — •
: Uses unleaded solder.
• Semiconductor
Location
Ref. No.
IC501
IC602
(Page 8)
IC607
D501
D601
D602
D603
D605
A-5
D-3
C-6
C-6
A-5
IC501
IC601
IC602
IC603
IC604
IC605
IC606
IC607
A-2
C-3
B-2
E-1
C-2
D-1
D-3
B-1
Q501
Q502
Q503
Q504
B-3
B-5
A-3
A-4
IC601
IC604
(Page 13)
IC605
IC606
IC603
15
15
Location
SA-WMS25
2-10. Schematic Diagram — DSP Board (1/2) — • See page 22 for IC Pin Function Description.
C657
100p
C653
0.1
C654
0.1
C655
0.1
R655
1k
C651
0.1
C652
100p
R657
100
R656
100
R654
100
FB609
0UH
R653
100
R650
IC603
IS61LV6416-15
T(ICSI)
FB605
0UH
C644
IC605
CXD9617R
0.1
FB604
0UH
R643
100
R642
10k
R619
100
R620
100
R621
100
R622
100
C645
0.1
X601
FB603
0UH
3216
TP607
C625
0.1
TP606
R623
100
R624
100
R625
100
R626
100
TP605
TP604
C635
0.1
TP603
R627
100
R628
100
R629
100
R633
10k
C634
0.1
R632
10k
C627
C609
0.1
JR602
13.5MHz
0.1
C628
100p
C626
0.1
16
16
C629
0.1
100
SA-WMS25
2-11. Schematic Diagram — DSP Board (2/2) — • See page 18 for IC Block Diagrams. • See page 20 for IC Pin Function Description.
R535 10k
C511
0.1
FB501
0UH
C508
47 16V
X501
5.0MHz
C512 0.1
R524 10k
R532 100
R533 100
R531 100
R528 1k
R529 100
R530 100
R526 1k
R525 1k
R527 1k
R534 1k
R522
10k
TP622
TP624
TP623
TP625
TP626
C510
0.1
R537 1k
C515
0.1
C513
0.01
R536 1k
R541 10k
C659
47 16V
C516
0.1
C509
0.1
C660
330 6.3V
C505
0.1
R540 10k
D603
11ES2-TB5
D602
11EQS04-TB5
IC607
NJM2391DL1-26
C658
0.1
CNS501
21P
D501
1SS355TE-17
R542 1k
CNP601
11P
C507
0.1
R523
10k
C504
0.1
C648
100p
R646
100
R644
1M
C647
47
16V
R652 100
R651 100
R647 1k
R648 100
C649 18p
R649 100
FB607 0UH
C650 18p
X602
R659 100 12.288MHz
R521
10k
C506
10 50V
R520 1k
R519 100
FB608
0UH
R645 10k
R518 100
D601
1SS355TE-17
IC501
R517 1k
R516 1k
C646
0.1
FB606
0UH
C502
0.1
C643
47
16V
R515 1k
R514 1k
R513 1k
C642
0.1
C641 0.01
R641 100
R638 4.7k
R639
33k
C501
0.1
R550
4.7k
R634
1k
R511 10k
R509 100
R508
100
R510 100
R507 1k
R506 1k
R503 1k
R501 1k
C638
0.1
R636
1k
R504 1k
IC606
LC89056W-E
R635
10k
CNP501
7P
C639
0.01
C636
47p
R505 1k
R637 5.6k
R502 1k
C637
0.1
C640
0.1
Q504
2SC2712
-YG-TE85L
FB601
0UH
C623
0.1
C624
0.1
C622
0.01
C632
0.01
C619
10
50V
R618
100
FB602
0UH
R614
100
C620
47 16V
R615
10k
R612
10k
R617
560k
R616
47k
IC602
TC7WU04F(TE12R)
R613
47k
C616
100
10V
C614 0.1
C617 C618
0.1 10 50V
R630
10k
JW601
C631
0.1
R631 10k
C630
1000p
R610 R611
22k
1k
IC604
PCM1800
E/2K
C613
1
C610
1p
R608
100
C611
0.1
Q502
2SC2712
-YG-TE85L
C514
0.01
R606 47k
C608
0.1
C602
470p
C603
0.1
R602 R607
4.7k 4.7k
C605
0.1
Q501
2SC2712
-YG-TE85L
R543
4.7k
C604
10
50V
C601
470p
D605
1SS355TE-17
R609
75
IC601
M5218AFP-T1
C612
47 16V
R601
1k
R545
4.7k
Q503
2SA1162
-YG-TE85L
R549
2.2k
C633
0.1
R658
2.2k
R548
10k
R603 R605
10k 10k
R604 47k
CNP602
13P
17
17
R544
1k
R546
R547 4.7k
10k
SA-WMS25
2-12. IC Block Diagrams
— DIGITAL AMP Board —
— DSP Board —
DVDD
VF/P3/C3
F2/P2/C2
F1/P1/C1
F0/P0/C0
CSFLAG
29 28 27 26 25
INA 6
REFCOM
3
ENA 7
V_REF_2
4
DIAGA 8
PROTECTOR
CIRCUIT
CROSS OVER
DELAY
LOW SIDE
LEVEL SHIFT
FILTER
HIGH SIDE
LEVEL SHIFT
PRE
DRIVER
PRE
DRIVER
+
−
+
−
VBBA
5TH-ORDER
DELTA-SIGMA
(-) MODULATOR
C_PR
7
18
VDD
FMT0
8
17
DGND
FMT1
9
16
SYSCLK
CKSEL0 46
CKSEL1 47
MODE0
10
15
DOUT
XMODE 48
MODE1
11
14
BCK
13
LRCK
CLOCK/TIMING CONTROL
RESET/POWER CONTROL
MODE/FORMAT
CONTROL
INTERFACE
DOUT
BCK
FSYNC
12
THERMAL
SHUT DOWN
ENB 17
PROTECTOR
CIRCUIT
CROSS OVER
DELAY
PRE
DRIVER
20
XSEL 39
BYPASS
INB 16
PRE
DRIVER
C_NL
C_NR
VDRVB
HIGH SIDE
LEVEL SHIFT
21
MICROCOMPUTER
INTERFACE
19
VBBB
LOW SIDE
LEVEL SHIFT
C_PL
6
VBOOTB 12
DIAGB 18
22
RSTB
SA 10
GNDB 15
SERIAL DATA
INTERFACE LRCK
FILTER
+
−
+
−
VBBB
VDRVB
VBBB
OUTB 19
SB 20
18
18
LRCK
C BIT
DETECT
CE 37
CL 38
5
FSYNC
UNDER
VOLTAGE
LOCK–OUT
VCC
(+)
OUTA 9
VDDB 14
23
BCK
FSYNC
SINGLE-END/
DIFFERENTIAL
CONVERTER
AGND
RIN
VBBA
VDRVA
X1/64
DECIMATION
AND
HIGH PASS FILTER
REFERENCE
24
DOUT
MODE0
MODE1
DGND
DVDD
DOSEL0
DOSEL1
40
41
42
43
44
45
24 AUDIO
23 EMPHA
PA/PB
DETECT
SAMPLING
FREQUENCY
LOCK
DETECT
22
21
20
19
18
17
16
15
14
13
CLOCK
MODE
SELECT
DATA
DEMODULATOR
SYSTEM
RESET
TIMING
PLL
INPUT
CIRCUIT
1
2 3
4
5
6 7
8 9 10
11 12
AVDD
AGND
2
5TH-ORDER
DELTA-SIGMA
(-) MODULATOR
R
VIN
LPF
V_REF_1
(+)
DGND
DVDD
THERMAL
SHUT DOWN
SINGLE-END/
DIFFERENTIAL
CONVERTER
DIN2
UNDER
VOLTAGE
LOCK–OUT
1
DINI
VDRVA
VDDA 4
VDRVB 13
30
DOUT
DIN0
LIN
GNDA 5
VBBB 11
36 35 34 33 32 31
VBBA
VBOOTA 2
VDRVA 3
IC606 LC89056W-E
DISEL
VBBA 1
IC604 PCM1800-E/2K
DI
DO
ERROR
BPSYNC
AUTO
DGND
IC301, 304, 306, 307, 309, 311
CXD9702L
XIN
XOUT
XMCK
DVDD
DGND
XSTATE
DATAO
LRCK
BCK
CKOUT
SA-WMS25
— PS Board —
IC901 STR-F6267D/STR-F6238S
DRIVE
REGULATOR
OVER
CURRENT
PROTECTOR
OVER
VOLTAGE
PROTECTOR
INH1
LATCH
START
THERMAL
SHUT DOWN
FEED BACK
INH2
OSC
OVER LOAD
PROTECTOR
REGULATOR
DRIVE
4
5
VCC
GND
3
FB/OLP
2
D
1
OCP/SYNC
CURRENT
MIRROR
IC903 SI-8120JF
IC907 SI-8050JF
IC910 NM2103M-TE2
OCP
PREG.
CT
1
VSC
2
8
RESET
7
VSA
6
VSB
5
VDD
LATCH &
DRIVE
RESET
–
OSC
TSD
COMP.
VREF
+
+ –
ERROR AMP
VREF
ON/OFF
SOFT
START
OUTC
3
GND
4
Q
R
1
2
3
4
5
VIN
SW
OUT
GND
VS
ON/OFF
S
+
–
+ –
19
SA-WMS25
2-13. IC Pin Function Description
• IC501
MB90478PFG-132-BND (MX:MB90478PFG-133-BND) SYSTEM CONTROL (DIGITAL AMP Board)
Pin No.
Pin Name
I/O
Description
1
XMODE
O
Reset signal output to the DIR (IC606)
2
CKSEL1
O
Clock selection signal output to the DIR (IC606)
3
CLK
O
Clock output to the DIR (IC606)
4
CE
O
Latch signal output to the DIR (IC606)
5
DI
O
Serial data output to the DIR (IC606)
6
DO
I
Serial data input from the DIR (IC606)
7
PD
O
Reset signal output to the A/D converter (IC604)
8
P27
—
General purpose I/O port Not used (ground)
9, 10
P30, P31
—
General purpose I/O port Not used (ground)
11
VSS
—
Ground
12 to 17
P32 to P37
—
General purpose I/O port Not used (ground)
18
HDOUT
I
Data input from the DSP (IC605)
19
HDIN
O
Data output to the DSP (IC605)
20
HCLK
O
Clock output to the DSP (IC605)
21, 22
P43, P44
—
General purpose I/O port Not used (ground)
23
VCC5
—
Power supply
24 to 26
P45 to P47
—
General purpose I/O port Not used (ground)
27
COMIN
I
UART serial data input from the display unit
28
COMOUT
O
UART serial data output to the display unit
29
P72
—
General purpose I/O port Not used (ground)
30
BUSYOUT
O
Busy signal output to the display unit
31 to 34
P74 to P77
—
General purpose I/O port Not used (ground)
35
AVCC
—
A/D converter power supply
36
AVRH
—
A/D converter external reference voltage source
37
AVSS
—
A/D converter power supply
38 to 41
P60 to P63
—
General purpose I/O port Not used (ground)
42
VSS
—
Ground
43 to 46
P64 to P67
—
General purpose I/O port Not used (ground)
47
P80
—
General purpose I/O port Not used ( fixed at H
“ )”
48
P81
—
General purpose I/O port Not used (ground)
49
MD0
I
Operation mode setting input (normally fixed at H
“ )”
50
MD1
I
Operation mode setting input (Vcc)
51
MD2
I
Operation mode setting input (normally fixed at L
“ )”
52
STOP
I
AC OFF signal input L
“ ” : AC OFF
53
P83
—
54
DIAG
I
Protection signal input from the power drivers
Not used (ground)
55
BUSYIN
I
Busy signal input from the display unit
56
AMPCE1
O
Latch signal output to the stream processor (IC305)
57
AMPCE2
O
Latch signal output to the stream processor (IC308)
58
AMPCE3
O
Latch signal output to the stream processor (IC318)
59
SDATA
O
Serial control data output to the stream processors (IC305, IC308 and IC318)
60
SSHIFT
O
Clock output to the stream processors (IC305, IC308 and IC318)
61
NSPMUTE
O
NSPMUTE signal output to the stream processors (IC305, IC308 and IC318)
62
PGMUTE
O
PGMUTE signal output to the stream processors (IC305, IC308 and IC318)
63
D/AOUT
O
Power supply voltage control signal output (0V to 2.9V)
64
RST
O
Reset signal output to the stream processors (IC305, IC308 and IC318)
65
P97
—
General purpose I/O port Not used (ground)
66
EN
O
Enable signal output to the power drivers
67 to 69
PA1 to PA3
—
General purpose I/O port Not used (ground)
70 to 74
P50 to P54
—
General purpose I/O port Not used (open)
20
SA-WMS25
Pin No.
Pin Name
I/O
Description
75
PWCNT2
O
Power supply (12V, 6.2V) control signal output to the power supply “H” : +12V and +6.2V ON
76
PWCNT1
O
Power supply ON/OFF control signal output to the power supply H
“ ” : ON
77
RSTX
I
Reset signal input
78
P57
—
General purpose I/O port Not used (ground)
79
X1A
—
32kHz oscillator terminal
80
X0A
—
32kHz oscillator terminal
81
VSS
—
Ground
82
X0
—
Oscillator terminal
83
X1
—
Oscillator terminal
84
VCC3
—
Power supply
85
P00
—
General purpose I/O port Not used (ground)
86
NC
—
General purpose I/O port Not used (ground)
87
GP9
I
GP9 signal input from the DSP (IC605)
88
BST
O
Boot strap signal output to the DSP (IC605)
89
HCS
O
Chip select signal output to the DSP (IC605)
90
HACN
I
Acknowledge signal input from the DSP (IC605)
91
XRST
O
Reset signal output to the DSP (IC605)
92
PM
O
PLL initialization signal output to the DSP (IC605)
93 to 97
P10 to P14
—
General purpose I/O port Not used (ground)
98
ERROR
I
Error signal input from the DIR (IC606)
99
XSTATE
I
XSTATE signal input from the DIR (IC606)
100
DATAO
I
Data existence check signal input from the DIR (IC606)
21
SA-WMS25
• IC605
Pin No.
CXD9617R (MX:CXD9689AR) DSP (DIGITAL AMP Board)
Pin Name
I/O
1
VSS
—
2
XRST
I
Reset signal input from the system control (IC501)
3
EXTIN
I
Not used (connected to ground)
Not used (connected to ground)
4
FS2
I
5
VDDI
—
Description
Ground
Power supply
6
FS1
I
Not used (connected to ground)
7
PLOCK
O
Internal PLL lock signal output (Not used (open))
8
VSS
—
Ground
9
MCLK1
I
10
VDDI
—
Power supply
11
VSS
—
Ground
12
MCLK2
O
Clock signal output (13.5 MHz) (resonator connection)
Clock signal input (13.5 MHz) (resonator connection)
13
MS
I
Switching of master/slave operation (L : internal clock, H : EXTIN clock is used)
14
SCKOUT
O
Internal system clock signal output
15
LRCKI1
I
Sampling clock input for audio serial data
16
VDDE
—
17
BCKI1
I
Bit clock input terminal for audio serial data
Power supply
18
SDI1
I
Audio IF data input
19
LRCKO
O
Sampling clock output for digital audio serial data
20
BCKO
O
Bit clock output terminal for digital audio serial data
21
VSS
—
Ground
22
KFSIO
I/O
Audio clock signal (364fs/256fs) input/output
23 to 25
SDO1 to SDO3
O
Digital audio serial data output
26
SDO4
O
Audio IF serial output (Not used (open))
27
SPDIF
O
Not used (open)
28
LRCKI2
I
Sampling clock input for audio serial data
29
BCKI2
I
Bit clock input terminal for audio serial data
30
SDI2
I
Digital audio data input
31
VSS
—
Ground
32
HACN
O
Acknowledge signal output to the system control (IC501)
33
HDIN
I
Serial data input from the system control (IC501)
34
HCLK
I
Clock input from the system control (IC501)
35
HDOUT
O
Serial data output to the system control (IC501)
36
HCS
I
Chip select signal input from the system control (IC501)
37
SDCLK
O
Not used (open)
38
CLKEN
O
Not used (open)
39
RAS
O
Not used (open)
40
VDDI
—
Power supply
41
VSS
—
Ground
42
CAS
O
Not used (open)
43
DQM/OE0
O
Not used (open)
44
CS0
O
External memory chip select (SRAM)
45
WE0
O
SRAM write enable output
46
VDDE
—
Power supply
47
WMD1
I
48
VSS
—
49
WMD0
I
Not used (connected to “H”)
50
PAGE2
O
Not used (open)
51
VSS
—
Ground
52
PAGE1
O
External memory page switching signal output (Not used (open))
22
Not used (connected to “H”)
Ground
SA-WMS25
Pin No.
Pin Name
I/O
Description
53
PAGE0
O
External memory page switching signal output (Not used (open))
54
BOOT
I
Not used (connected to ground)
55
BTACT
O
Not used (open)
56
BST
I
Boot strap signal input from the system control (IC501)
57
MOD1
I
Operation mode signal input (L : 386fs, H : 256fs)
58
MOD0
I
Operation mode signal input (L : single chip mode, H : use prohibited)
59
EXLOCK
I
Lock signal input
60
VDDI
—
Power supply
61
VSS
—
Ground
62, 63
A17, A16
O
Not used (open)
64 to 66
A15 to A13
O
External memory address output (SRAM)
67
GP10
O
LRCKO
68
GP9
O
DECODE
69
GP8
I
AUDIO
70
VDDI
—
Power supply
71
VSS
72 to 75 D15/GP7 to D12/GP4
76
VDDE
77 to 80 D11/GP3 to D8/GP0
—
Ground
I/O
External memory data input/output (general port)
—
Power supply
I/O
External memory data input/output (general port)
81
VSS
—
Ground
82
A9
O
External memory address output (SRAM)
83 to 85
A12 to A10
O
External memory address output (SRAM)
86
TDO
O
Not used (open)
87
TMS
I
Not used (open)
88
XTRST
I
Not used (open)
89
TCK
I
Not used (open)
Not used (open)
90
TDI
I
91
VSS
—
Ground
92 to 97
A8 to A3
O
External memory address output (SRAM)
98, 99
D7, D6
I/O
External memory data input/output (SRAM)
100
VDDI
—
Power supply
101
VSS
—
Ground
102 to 105
D5 to D2
I/O
External memory data input/output (SRAM)
106
VDDE
—
Power supply
107, 108
D1, D0
I/O
External memory data input/output (SRAM)
109, 110
A2, A1
O
External memory address output (SRAM)
111
VSS
—
Ground
112
A0
O
External memory address output (SRAM)
113
PM
I
PLL initialization input terminal
114, 115
SDI3, SDI4
I
Not used (open)
Sync/async selection input (L : sync, H : async)
116
SYNC
I
117 to 119
VSS
—
Ground
200
VDDI
—
Power supply
23
SA-WMS25
SECTION 3
EXPLODED VIEWS
NOTE:
• Items marked *“ ” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
•
The mechanical parts with no reference number
in the exploded views are not supplied.
• Abbreviation
MX : Mexican model
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
3-1. Cabinet Section
#1
AMP section
not
supplied
#1
#1
2
not
supplied
not
supplied
1
#2
SP1
not
supplied
#1
#1
not
supplied
#1
#1
#1
Ref. No.
1
2
24
Part No.
Description
9-831-273-66 WIRE KIT
A-4722-848-A PANEL ASSY, FRONT
Remarks
Ref. No.
SP1
#1
Part No.
Description
1-825-188-11 SPEAKER (16CM)
7-685-564-01 SCREW +BTP 4X20 TYPE1
Remarks
SA-WMS25
3-2. AMP Section
#2
not
supplied
54
not
supplied
#2
53
#2
#2
F901
56
not
supplied
not
supplied
55
#2
#2
#2
52
Ref. No.
Part No.
Description
0 51
0 51
* 52
53
54
1-769-744-11
1-783-525-41
3-703-244-00
A-4729-917-A
A-4729-911-A
CORD, POWER (EXCEPT MX)
CORD, POWER (TRACKING) (MX)
BUSHING (2104), CORD
DIGITAL AMP BOARD, COMPLETE
PS BOARD, COMPLETE (EXCEPT MX)
54
A-4730-126-A PS BOARD, COMPLETE (MX)
51
Remarks
Ref. No.
Part No.
Description
55
56
56
0 F901
0 F901
1-775-188-11
A-4729-914-A
A-4730-129-A
1-532-465-31
1-532-747-11
WIRE (FLAT TYPE) (21 CORE)
DSP BOARD, COMPLETE (EXCEPT MX)
DSP BOARD, COMPLETE (MX)
FUSE (T3.15AL/250V) (EXCEPT MX)
FUSE, GLASS TUBE (5A/125V) (MX)
#2
Remarks
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
25
SA-WMS25
SECTION 4
ELECTRICAL PARTS LIST
DIGITAL AMP
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they may
have some difference from the original one.
• Items marked *“ ” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
Ref. No.
Part No.
•
•
•
CAPACITORS:
uF: µF
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: µH
When indicating parts by reference number,
please include the board name.
Description
Remarks
A-4729-917-A DIGITAL AMP BOARD, COMPLETE
***************************
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
C301
C302
C303
C304
C305
1-126-382-11
1-162-970-11
1-136-157-00
1-136-157-00
1-165-319-11
ELECT
CERAMIC CHIP
FILM
FILM
CERAMIC CHIP
100uF
0.01uF
0.022uF
0.022uF
0.1uF
20.00%
10%
5%
5%
C306
C307
C308
C309
C310
1-162-970-11
1-162-910-11
1-162-964-11
1-126-953-11
1-104-665-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.01uF
5PF
0.001uF
2200uF
100uF
10%
0.25PF
10%
20.00%
20.00%
C311
C312
C313
C314
C315
1-162-970-11
1-104-665-11
1-136-165-00
1-165-319-11
1-104-665-11
CERAMIC CHIP
ELECT
FILM
CERAMIC CHIP
ELECT
0.01uF
100uF
0.1uF
0.1uF
100uF
10%
25V
20.00% 10V
5%
50V
50V
20.00% 10V
C316
C317
C318
C319
C320
1-165-319-11
1-126-948-11
1-104-665-11
1-165-319-11
1-165-319-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
100uF
0.1uF
0.1uF
50V
20.00% 35V
20.00% 10V
50V
50V
C321
C322
C323
C324
C325
1-104-665-11
1-165-319-11
1-104-665-11
1-165-319-11
1-126-948-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100uF
0.1uF
100uF
0.1uF
100uF
20.00% 10V
50V
20.00% 10V
50V
20.00% 35V
C326
C327
C328
C329
C330
1-126-786-11
1-162-970-11
1-162-970-11
1-104-665-11
1-165-319-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
47uF
0.01uF
0.01uF
100uF
0.1uF
20.00%
10%
10%
20.00%
C331
C332
C333
C334
C335
1-162-970-11
1-136-165-00
1-136-157-00
1-136-157-00
1-104-665-11
CERAMIC CHIP
FILM
FILM
FILM
ELECT
0.01uF
0.1uF
0.022uF
0.022uF
100uF
10%
5%
5%
5%
20.00%
C336
C337
C338
C339
C340
1-126-382-11
1-104-665-11
1-165-319-11
1-165-319-11
1-126-948-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
100uF
0.1uF
0.1uF
100uF
20.00% 10V
20.00% 10V
50V
50V
20.00% 35V
C341
1-165-319-11 CERAMIC CHIP
0.1uF
50V
26
10V
25V
50V
50V
50V
25V
50V
50V
35V
10V
16V
25V
25V
10V
50V
25V
50V
50V
50V
10V
Ref. No.
•
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
• Abbreviation
MX : Mexican model
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Part No.
Description
C342
C343
C344
C345
1-126-948-11
1-165-319-11
1-162-970-11
1-104-665-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
0.1uF
0.01uF
100uF
20.00% 35V
50V
10%
25V
20.00% 10V
Remarks
C346
C347
C348
C349
C350
1-104-665-11
1-165-319-11
1-162-970-11
1-162-970-11
1-104-665-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
0.1uF
0.01uF
0.01uF
100uF
20.00% 10V
50V
10%
25V
10%
25V
20.00% 10V
C351
C352
C353
C354
C355
1-162-970-11
1-162-970-11
1-136-165-00
1-136-157-00
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
0.022uF
0.01uF
10%
10%
5%
5%
10%
25V
25V
50V
50V
25V
C356
C357
C358
C359
C360
1-136-157-00
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.01uF
0.01uF
0.01uF
0.01uF
5%
10%
10%
10%
10%
50V
25V
25V
25V
25V
C361
C362
C363
C364
C365
1-162-970-11
1-104-665-11
1-165-319-11
1-126-948-11
1-165-319-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
100uF
0.1uF
100uF
0.1uF
10%
25V
20.00% 10V
50V
20.00% 35V
50V
C366
C367
C368
C369
C370
1-162-970-11
1-162-970-11
1-165-319-11
1-136-157-00
1-136-157-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
0.01uF
0.01uF
0.1uF
0.022uF
0.022uF
10%
10%
5%
5%
25V
25V
50V
50V
50V
C371
C372
C373
C374
C375
1-136-165-00
1-162-970-11
1-162-970-11
1-136-165-00
1-136-157-00
FILM
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
0.1uF
0.01uF
0.01uF
0.1uF
0.022uF
5%
10%
10%
5%
5%
50V
25V
25V
50V
50V
C376
C377
C378
C379
C380
1-136-157-00
1-162-970-11
1-162-970-11
1-162-970-11
1-164-315-11
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.01uF
0.01uF
0.01uF
470PF
5%
10%
10%
10%
5.00%
50V
25V
25V
25V
50V
C381
C382
C383
C384
C385
1-104-665-11
1-165-319-11
1-126-948-11
1-165-319-11
1-164-315-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
100uF
0.1uF
470PF
20.00% 10V
50V
20.00% 35V
50V
5.00% 50V
C386
C387
C388
1-164-315-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
470PF
0.01uF
0.01uF
5.00% 50V
10%
25V
10%
25V
SA-WMS25
DIGITAL AMP
Ref. No.
Part No.
Description
Remarks
C389
C390
1-104-665-11 ELECT
1-162-970-11 CERAMIC CHIP
100uF
0.01uF
20.00% 10V
10%
25V
C391
C392
C393
C394
C395
1-162-970-11
1-126-382-11
1-162-970-11
1-162-970-11
1-136-165-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
FILM
0.01uF
100uF
0.01uF
0.01uF
0.1uF
10%
20.00%
10%
10%
5%
25V
10V
25V
25V
50V
C396
C397
C398
C399
C401
1-136-157-00
1-136-157-00
1-162-970-11
1-162-970-11
1-131-704-11
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
FILM
0.022uF
0.022uF
0.01uF
0.01uF
1uF
5%
5%
10%
10%
5%
50V
50V
25V
25V
50V
C402
C403
C404
C405
C406
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
FILM
FILM
FILM
FILM
FILM
1uF
1uF
1uF
1uF
1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C407
C408
C409
C410
C412
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
FILM
FILM
FILM
FILM
FILM
1uF
1uF
1uF
1uF
1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C413
C414
C415
C416
C417
1-131-704-11
1-136-165-00
1-136-165-00
1-136-165-00
1-136-165-00
FILM
FILM
FILM
FILM
FILM
1uF
0.1uF
0.1uF
0.1uF
0.1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C418
C419
C420
C421
C422
1-136-165-00
1-136-165-00
1-136-165-00
1-136-165-00
1-136-165-00
FILM
FILM
FILM
FILM
FILM
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C423
C425
C426
C427
C428
1-136-165-00
1-136-165-00
1-136-165-00
1-117-720-11
1-117-720-11
FILM
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
4.7uF
4.7uF
5%
5%
5%
50V
50V
50V
10V
10V
C429
C430
C431
C432
C433
1-117-720-11
1-117-720-11
1-117-720-11
1-162-915-11
1-117-720-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
4.7uF
10PF
4.7uF
C434
1-164-156-11 CERAMIC CHIP
0.1uF
0.5PF
10V
10V
10V
50V
10V
25V
Ref. No.
Part No.
Description
D315
D316
D321
D322
6-500-131-01
6-500-131-01
6-500-131-01
6-500-131-01
DIODE
DIODE
DIODE
DIODE
LI116
LI116
LI116
LI116
Remarks
D323
D324
D325
D326
D331
6-500-131-01
6-500-131-01
6-500-131-01
6-500-131-01
6-500-060-01
DIODE
DIODE
DIODE
DIODE
DIODE
LI116
LI116
LI116
LI116
P6SMB36AT3
D332
D333
D334
D335
D336
6-500-060-01
6-500-060-01
6-500-060-01
6-500-060-01
6-500-060-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
D341
D342
D343
D344
D345
6-500-060-01
6-500-060-01
6-500-060-01
6-500-060-01
6-500-060-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
P6SMB36AT3
D346
D351
D352
D353
D354
6-500-060-01
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMB36AT3
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
D355
D356
D361
D362
D363
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
DIODE
DIODE
DIODE
DIODE
DIODE
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
D364
D365
D366
D401
D402
6-500-248-01
6-500-248-01
6-500-248-01
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
SFPL-62V
SFPL-62V
SFPL-62V
1SS355TE-17
1SS355TE-17
D403
D404
D405
D406
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
< FERRITE BEAD >
FB300
FB301
FB302
FB304
FB305
1-469-152-11
1-469-152-11
1-469-152-11
1-469-152-11
1-469-152-11
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0UH
0UH
0UH
0UH
0UH
FB314
FB315
1-469-152-11 FERRITE
1-469-152-11 FERRITE
0UH
0UH
< CONNECTOR >
CNP301
* CNP302
CNP401
CNS301
1-784-924-11
1-564-704-11
1-564-320-00
1-778-692-11
PIN, CONNECTOR 8P
PIN, CONNECTOR (SMALL TYPE) 2P
PIN, CONNECTOR(3.96MM PITCH)2P
CONNECTOR, FFC/FPC 21P
< DIODE >
D301
D302
D311
D312
D313
8-719-200-82
8-719-085-36
6-500-131-01
6-500-131-01
6-500-131-01
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-TB5
11EQS04-TB5
LI116
LI116
LI116
D314
6-500-131-01 DIODE LI116
< IC >
IC300
IC301
IC304
IC305
IC306
6-701-189-01
6-701-845-01
6-701-845-01
6-702-673-01
6-701-845-01
IC
IC
IC
IC
IC
MC74VHC1GU04DFT1
CXD9702L
CXD9702L
CXD9730Q
CXD9702L
IC307
IC308
IC309
IC311
6-701-845-01
6-702-673-01
6-701-845-01
6-701-845-01
IC
IC
IC
IC
CXD9702L
CXD9730Q
CXD9702L
CXD9702L
27
SA-WMS25
DIGITAL AMP
Ref. No.
IC318
Part No.
DSP
Description
Remarks
6-702-673-01 IC CXD9730Q
< JACK >
J401
1-694-656-21 TERMINAL BOARD (6CH SPEAKER)
(SPEAKER OUT)
< COIL >
L302
L401
L402
L403
L404
1-410-369-11
1-456-220-11
1-456-220-11
1-456-220-11
1-456-220-11
INDUCTOR CHIP
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
L405
L406
1-456-220-11 INDUCTOR
1-456-220-11 INDUCTOR
1uH
10uH
10uH
10uH
10uH
10uH
10uH
< TRANSISTOR >
Q328
Q401
Q402
Q403
Q404
8-729-024-91
8-729-216-22
8-729-216-22
8-729-216-22
8-729-216-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-GL-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
Q405
Q406
Q411
Q412
Q413
8-729-216-22
8-729-216-22
8-729-216-22
8-729-216-22
8-729-216-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
Q414
Q415
Q416
8-729-216-22 TRANSISTOR
8-729-216-22 TRANSISTOR
8-729-216-22 TRANSISTOR
2SA1162-YG-TE85L
2SA1162-YG-TE85L
2SA1162-YG-TE85L
Ref. No.
Part No.
Description
R346
R347
R348
R349
1-216-821-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
100
100
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
R350
R370
R401
R402
R403
1-216-809-11
1-216-819-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
680
220K
220K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R404
R405
R406
R407
R408
1-216-849-11
1-216-849-11
1-216-849-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
220K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R411
R412
R413
R414
R415
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
220K
220K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R416
1-216-849-11 METAL CHIP
220K
5%
1/16W
< VIBRATOR >
X301
1-795-286-21 VIBRATOR, CRYSTAL (49.152MHz)
************************************************************
A-4729-914-A DSP BOARD, COMPLETE (EXCEPT MX)
A-4730-129-A DSP BOARD, COMPLETE (MX)
*******************************
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S (EXCEPT MX)
< RESISTOR >
< CAPACITOR >
R302
R304
R305
R307
R315
1-216-857-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C501
C502
C504
C505
C506
1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-126-795-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.1uF
10uF
25V
25V
25V
25V
20.00% 50V
R316
R317
R318
R319
R320
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C507
C508
C509
C510
C511
1-164-156-11
1-126-786-11
1-164-156-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.1uF
0.1uF
0.1uF
25V
20.00% 16V
25V
25V
25V
R321
R322
R325
R330
R333
1-216-809-11
1-216-809-11
1-216-801-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
22
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C512
C513
C514
C515
C516
1-164-156-11
1-162-970-11
1-162-970-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.1uF
0.1uF
R334
R335
R336
R338
R339
1-216-821-11
1-216-809-11
1-216-821-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
1K
1K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C601
C602
C603
C604
C605
1-164-315-11
1-164-315-11
1-164-156-11
1-126-795-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
470PF
470PF
0.1uF
10uF
0.1uF
5.00% 50V
5.00% 50V
25V
20.00% 50V
25V
R340
R341
R342
R343
R344
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C608
C609
C610
C611
C612
1-164-156-11
1-164-156-11
1-162-905-11
1-164-156-11
1-126-786-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
1PF
0.1uF
47uF
25V
25V
0.25PF 50V
25V
20.00% 16V
R345
1-216-821-11 METAL CHIP
1K
5%
1/16W
C613
1-165-908-91 CERAMIC CHIP
1uF
10%
28
10%
10%
25V
25V
25V
25V
25V
10V
SA-WMS25
DSP
Ref. No.
Part No.
Description
C614
C616
C617
C618
1-164-156-11
1-126-382-11
1-164-156-11
1-126-795-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.1uF
100uF
0.1uF
10uF
Remarks
25V
20.00% 10V
25V
20.00% 50V
C619
C620
C622
C623
C624
1-126-795-11
1-126-786-11
1-162-974-11
1-164-156-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
47uF
0.01uF
0.1uF
0.1uF
20.00% 50V
20.00% 16V
50V
25V
25V
C625
C626
C627
C628
C629
1-164-156-11
1-164-156-11
1-164-156-11
1-162-927-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
100PF
0.1uF
25V
25V
25V
50V
25V
C630
C631
C632
C633
C634
1-162-964-11
1-164-156-11
1-162-974-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.01uF
0.1uF
0.1uF
C635
C636
C637
C638
C639
1-164-156-11
1-162-923-11
1-164-156-11
1-164-156-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47PF
0.1uF
0.1uF
0.01uF
C640
C641
C642
C643
C644
1-164-156-11
1-162-974-11
1-164-156-11
1-126-786-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.01uF
0.1uF
47uF
0.1uF
25V
50V
25V
20.00% 16V
25V
C645
C646
C647
C648
C649
1-164-156-11
1-164-156-11
1-126-786-11
1-162-927-11
1-162-918-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47uF
100PF
18PF
25V
25V
20.00% 16V
5%
50V
5.00% 50V
C650
C651
C652
C653
C654
1-162-918-11
1-164-156-11
1-162-927-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
18PF
0.1uF
100PF
0.1uF
0.1uF
5.00% 50V
25V
5%
50V
25V
25V
C655
C657
C658
C659
C660
1-164-156-11
1-162-927-11
1-164-156-11
1-126-786-11
1-126-245-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
100PF
0.1uF
47uF
330uF
25V
50V
25V
20.00% 16V
20.00% 6.3V
5%
10%
5%
50V
25V
50V
25V
25V
25V
50V
25V
25V
50V
Ref. No.
< CONNECTOR >
CNP501
CNP601
CNP602
CNS501
1-564-723-11
1-784-926-11
1-816-826-11
1-784-833-21
PIN, CONNECTOR (SMALL TYPE) 7P
PIN, CONNECTOR 11P
SOCKET, CONNECTOR (DIN) 13P (CONTROL)
CONNECTOR,FFC(LIF(NON-ZIF))21P
< DIODE >
D501
D601
D602
D603
D605
8-719-988-61
8-719-988-61
8-719-085-36
8-719-200-82
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
11EQS04-TB5
11ES2-TB5
1SS355TE-17
Description
Remarks
< FERRITE BEAD >
FB501
FB601
FB602
FB603
FB604
1-469-152-11
1-469-152-11
1-469-152-11
1-469-450-21
1-469-140-21
FERRITE
FERRITE
FERRITE
INDUCTOR
FERRITE
0UH
0UH
0UH
0UH
0UH
FB605
FB606
FB607
FB608
FB609
1-469-152-11
1-469-152-11
1-469-152-11
1-469-140-21
1-469-140-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0UH
0UH
0UH
0UH
0UH
< IC >
IC501
IC601
IC602
IC603
IC604
6-802-156-01
8-759-636-55
8-759-242-70
6-700-983-01
8-759-560-56
IC605
IC606
IC607
8-759-698-76 IC CXD9617R
8-759-825-15 IC LC89056W-E
8-759-835-63 IC NJM2391DL1-26(TE1)
IC
IC
IC
IC
IC
MB90478PFG-132-BND
M5218AFP-T1
TC7WU04F(TE12R)
IS61LV6416-15T(ICSI)
PCM1800E/2K
< JUMPER RESISTOR >
JR602
5%
Part No.
1-216-295-91 SHORT CHIP
0
< TRANSISTOR >
Q501
Q502
Q503
Q504
8-729-230-49
8-729-230-49
8-729-216-22
8-729-230-49
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-YG-TE85L
2SC2712-YG-TE85L
2SA1162-YG-TE85L
2SC2712-YG-TE85L
< RESISTOR >
R501
R502
R503
R504
R505
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R506
R507
R508
R509
R510
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R511
R513
R514
R515
R516
1-216-833-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R517
R518
R519
R520
R521
1-216-821-11
1-216-809-11
1-216-809-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R522
R523
R524
R525
R526
1-216-833-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
29
SA-WMS25
DSP
Ref. No.
LED
PS
Part No.
Description
R527
R528
R529
R530
R531
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
100
100
5%
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
1/16W
R532
R533
R534
R535
R536
1-216-809-11
1-216-809-11
1-216-821-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
10K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R537
R540
R541
R542
R543
1-216-821-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
10K
1K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R544
R545
R546
R547
R548
1-216-821-11
1-216-829-11
1-216-829-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
4.7K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R549
R550
R601
R602
R603
1-216-825-11
1-216-829-11
1-216-821-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
4.7K
1K
4.7K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R604
R605
R606
R607
R608
1-216-841-11
1-216-833-11
1-216-841-11
1-216-829-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
47K
4.7K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R609
R610
R611
R612
R613
1-218-285-11
1-216-837-11
1-216-821-11
1-216-833-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
75
22K
1K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R614
R615
R616
R617
R618
1-216-809-11
1-216-833-11
1-216-841-11
1-216-854-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
47K
560K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R619
R620
R621
R622
R623
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R624
R625
R626
R627
R628
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R629
R630
R631
R632
R633
1-216-809-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R634
R635
R636
1-216-821-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-821-11 METAL CHIP
1K
10K
1K
5%
5%
5%
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
Remarks
R637
R638
1-216-830-11 METAL CHIP
1-216-829-11 METAL CHIP
5.6K
4.7K
5%
5%
1/16W
1/16W
R639
R641
R642
R643
R644
1-216-839-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
100
10K
100
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R645
R646
R647
R648
R649
1-216-833-11
1-216-809-11
1-216-821-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
1K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R650
R651
R652
R653
R654
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R655
R656
R657
R658
R659
1-216-821-11
1-216-809-11
1-216-809-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
2.2K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< VIBRATOR >
X501
1-760-489-11 VIBRATOR, CERAMIC (5.0MHz)
X601
1-795-363-21 VIBRATOR, CERAMIC (13.5MHz)
X602
1-781-465-21 VIBRATOR, CRYSTAL (12.288MHz)
************************************************************
LED BOARD
**********
< CONNECTOR >
* CNP303 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P
< DIODE >
D303
8-719-071-42 DIODE SEL5723C-TP15 (POWER)
< RESISTOR >
R301
1-216-813-11 METAL CHIP
220
5%
1/16W
************************************************************
A-4729-911-A PS BOARD, COMPLETE (EXCEPT MX)
A-4730-126-A PS BOARD, COMPLETE (MX)
******************************
1-533-293-11 FUSE HOLDER
< CAPACITOR >
0 C901
0 C902
0 C903
0 C905
0 C906
1-126-963-11
1-104-705-11
1-104-705-11
1-162-968-11
1-117-699-11
0 C907
0 C908
0 C909
ELECT
MYLAR
MYLAR
CERAMIC CHIP
CERAMIC
4.7uF
0.1uF
0.1uF
0.0047uF
0.001uF
20.00%
20.00%
20.00%
10%
99%
1-117-699-11 CERAMIC
0.001uF
99%
1-164-816-11 CERAMIC CHIP
1-117-699-11 CERAMIC
220PF
0.001uF
50V
250V
250V
50V
250V
(MX)
250V
(MX)
2.00% 50V
99%
250V
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
30
SA-WMS25
PS
Ref. No.
Part No.
0 C910
0 C911
1-117-699-11 CERAMIC
1-126-967-11 ELECT
Description
0.001uF
47uF
99%
250V
20.00% 50V
Remarks
0 C912
1-165-626-11 ELECT
390uF
0 C912
1-137-994-11 ELECT
820uF
0 C913
1-117-452-11 FILM
3300PF
0 C913
1-136-203-11 FILM
10000PF
C914
1-164-156-11 CERAMIC CHIP
0.1uF
20%
400V
(EXCEPT MX)
20%
200V
(MX)
5.00% 630V
(EXCEPT MX)
5.00% 630V
(MX)
25V
0 C915
1-115-416-11 CERAMIC CHIP
0.001uF
0 C915
1-162-965-11 CERAMIC CHIP
0 C916
1-104-332-11 CERAMIC
0 C916
1-117-452-11 FILM
0 C917
1-117-699-11 CERAMIC
5.00% 25V
(EXCEPT MX)
0.0015uF 10%
50V
(MX)
470PF
10.00% 2KV
(EXCEPT MX)
3300PF
5.00% 630V
(MX)
0.001uF 99%
250V
(MX)
C918
C920
C921
C922
C924
1-165-319-11
1-117-454-11
1-100-357-11
1-126-960-11
1-126-953-11
CERAMIC CHIP
FILM
ELECT
ELECT
ELECT
0.1uF
4700PF
6800uF
1uF
2200uF
C925
C926
C927
C928
C929
1-162-970-11
1-162-927-11
1-165-319-11
1-115-416-11
1-104-665-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
100PF
0.1uF
0.001uF
100uF
25V
50V
50V
5.00% 25V
20.00% 10V
C930
C931
C932
C933
C934
1-164-156-11
1-164-156-11
1-164-156-11
1-165-319-11
1-126-767-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.1uF
1000uF
25V
25V
25V
50V
20.00% 16V
C935
0 C936
0 C938
C939
C940
1-126-767-11
1-117-699-11
1-115-416-11
1-126-957-11
1-165-319-11
ELECT
CERAMIC
CERAMIC CHIP
ELECT
CERAMIC CHIP
1000uF
0.001uF
0.001uF
0.22uF
0.1uF
20.00%
99%
5.00%
20.00%
22uF
100uF
100uF
20.00% 25V
20.00% 10V
20.00% 10V
C942
C943
C944
1-128-551-11 ELECT
1-104-665-11 ELECT
1-104-665-11 ELECT
5.00%
20%
20.00%
20.00%
50V
630V
35V
50V
35V
Ref. No.
Part No.
Description
D913
D914
D916
D918
0 D919
8-719-988-61
8-719-085-36
8-719-085-36
8-719-085-36
6-500-408-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
11EQS04-TB5
11EQS04-TB5
11EQS04-TB5
11ES4-TB5
Remarks
0 D920
0 D931
0 D932
0 D933
6-500-408-01
8-719-083-67
8-719-083-85
8-719-085-37
DIODE
DIODE
DIODE
DIODE
11ES4-TB5
UDZSTE-1720B
UDZS-TE17-22B
11EQS10-TB5
< IC >
0 IC901
0 IC901
IC902
IC903
IC904
6-703-098-01
6-702-338-01
6-700-388-01
6-701-021-01
8-759-970-89
IC
IC
IC
IC
IC
STR-F6267D (EXCEPT MX)
STR-F6238S (MX)
SE-B2
SI-8120JF
BA10358F-T1
IC905
IC906
IC907
IC908
IC910
8-759-450-47
8-759-445-59
6-700-812-01
8-759-445-59
8-759-544-04
IC
IC
IC
IC
IC
BA05T
BA033T
SI-8050JF
BA033T
NJM2103M-TE2
< JUMPER RESISTOR >
JR901
1-216-864-11 METAL CHIP
0
5%
JR902
1-216-864-11 METAL CHIP
0
5%
10%
5%
16V
250V
25V
50V
50V
1/16W
(MX)
1/16W
(MX)
< COIL >
L901
L902
L903
L904
L905
1-424-860-11
1-414-398-11
1-414-398-11
1-414-398-11
1-414-398-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
L906
L907
L909
1-419-253-11 INDUCTOR
1-216-296-11 SHORT CHIP
1-419-253-11 INDUCTOR
10uH
10uH
10uH
10uH
10uH
100uH
0
100uH
< LINE FILTER >
0 LF901
0 LF901
0 LF902
0 LF902
1-424-930-11
1-428-906-11
1-424-930-11
1-428-906-11
COIL, LINE FILTER (EXCEPT MX)
COIL, LINE FILTER (MX)
COIL, LINE FILTER (EXCEPT MX)
COIL, LINE FILTER (MX)
< IC >
< CONNECTOR >
CNP901 1-564-321-00 PIN, CONNECTOR(3.96MM PITCH)2P
0 PC901
0 PC902
8-749-019-04 IC TLP421
8-749-019-04 IC TLP421
< DIODE >
0 D902
0 D903
0 D903
D905
0 D906
8-719-085-37
8-719-084-58
8-719-022-92
8-719-978-33
8-719-085-37
DIODE
DIODE
DIODE
DIODE
DIODE
11EQS10-TB5
RBV-406 (EXCEPT MX)
RBV-604 (MX)
UDZSTE-176.8B
11EQS10-TB5
0 D907
0 D908
D911
D912
D912
8-719-085-37
6-500-241-01
8-719-313-14
8-719-069-55
8-719-069-56
DIODE
DIODE
DIODE
DIODE
DIODE
11EQS10-TB5
SARS03
FML-22S
UDZSTE-175.6B (EXCEPT MX)
UDZSTE-176.2B (MX)
< TRANSISTOR >
Q901
Q902
Q903
0 Q905
Q906
Q908
Q913
Q915
8-729-027-43
8-729-901-81
8-729-027-43
8-729-111-29
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1N141C-TP-1
2SC2412K-T-146-R
RT1N141C-TP-1
2SD1616A-TP-LK
RT1N141C-TP-1
8-729-027-43 TRANSISTOR
8-729-901-81 TRANSISTOR
8-729-901-81 TRANSISTOR
RT1N141C-TP-1
2SC2412K-T-146-R
2SC2412K-T-146-R
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
31
SA-WMS25
PS
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
< RESISTOR >
Description
Remarks
< TRANSFORMER >
0 R901
0 R902
1-216-033-00 METAL CHIP
1-245-391-81 METAL OXIDE
220
0.12
0 R903
1-245-392-51 METAL OXIDE
0.15
0 R903
1-245-391-81 METAL OXIDE
0.12
0 R904
1-216-341-11 METAL OXIDE
0.22
5%
5%
1/10W
1W
(MX)
5%
1W
(EXCEPT MX)
5%
1W
(MX)
5%
1W
(EXCEPT MX)
0 R904
1-245-391-81 METAL OXIDE
0.12
0 R905
1-216-063-91 RES-CHIP
3.9K
0 R905
1-216-061-91 RES-CHIP
3.3K
R906
0 R907
1-216-833-11 METAL CHIP
1-216-065-91 RES-CHIP
10K
4.7K
(MX)
1/10W
(EXCEPT MX)
5%
1/10W
(MX)
5%
1/16W
5%
1/10W
0 R908
1-215-902-61 METAL OXIDE
47K
5%
0 R908
1-215-901-61 METAL OXIDE
33K
5%
0 R909
1-215-901-61 METAL OXIDE
33K
5%
0 R909
1-215-903-61 METAL OXIDE
68K
5%
0 R911
1-215-901-61 METAL OXIDE
33K
5%
0 R912
0 R913
R914
R915
R916
1-216-053-00
1-249-387-11
1-216-826-11
1-216-826-11
1-216-051-00
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
3.3
2.7K
2.7K
1.2K
5%
5%
5%
5%
5%
R916
1-216-057-91 METAL CHIP
2.2K
5%
R917
R918
R919
R920
1-216-059-00
1-216-821-11
1-216-675-91
1-216-659-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.7K
1K
10K
2.2K
1/10W
(EXCEPT MX)
5%
1/10W
5%
1/16W
0.5% 1/10W
0.5% 1/10W
R923
R924
R925
R926
R927
1-216-841-11
1-216-821-11
1-216-821-11
1-216-833-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
1K
10K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R928
R929
0 R930
R931
R932
1-216-835-11
1-216-821-11
1-219-237-11
1-216-812-11
1-216-826-11
METAL CHIP
METAL CHIP
SOLID
METAL CHIP
METAL CHIP
15K
1K
3.3M
180
2.7K
5%
5%
20%
5%
5%
1/16W
1/16W
1/2W
1/16W
1/16W
R933
0 R934
1-216-820-11 METAL CHIP
1-215-901-61 METAL OXIDE
820
33K
5%
5%
R935
R936
R937
1-216-833-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
10K
1K
1K
1/16W
2W
(EXCEPT MX)
5%
1/16W
5%
1/16W
5%
1/16W
0 R938
1-216-847-11 METAL CHIP
150K
5%
5%
0 T901
0 T901
1-437-865-11 TRANSFORMER, POWER (MX)
1-437-866-11 TRANSFORMER, POWER (EXCEPT MX)
< THERMISTOR >
0 TH901 1-803-916-11 THERMISTOR, NTC
************************************************************
MISCELLANEOUS
***************
1W
5%
1
0 51
0 51
55
0 F901
9-831-273-66
1-769-744-11
1-783-525-41
1-775-188-11
1-532-465-31
WIRE KIT
CORD, POWER (EXCEPT MX)
CORD, POWER (TRACKING) (MX)
WIRE (FLAT TYPE) (21 CORE)
FUSE (T3.15AL/250V) (EXCEPT MX)
0 F901
SP1
1-532-747-11 FUSE, GLASS TUBE (5A/125V) (MX)
1-825-188-11 SPEAKER (16CM) (WOOFER)
2W
(EXCEPT MX)
2W
(MX)
2W
(EXCEPT MX)
2W
(MX)
2W
(EXCEPT MX)
1/10W
1/4W F
1/16W
1/16W
1/10W
(MX)
1/16W
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
32
SA-WMS25
MEMO
33
SA-WMS25
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
Date
1.0
2002.09
Description of Revision
New