Download VPL-CS1/RM-PJM1 Service Manual

SERVICE MANUAL
MODEL
...............
DEST.
..........
MODEL
...............
DEST.
..........
VPL-CS1
WORLD
RM-PJM1
WORLD
LCD VIDEO PROJECTOR
R
! WARNING
This manual is intended for qualified service personnel only.
To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that
contained in the operating instructions unless you are qualified to do so. Refer all servicing to
qualified service personnel.
! WARNUNG
Die Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.
Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um die
Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei
Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben
Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung
dazu besitzen.
! AVERTISSEMENT
Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin
de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les
réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.
Pour toute réparation faire appel à une personne compétente uniquement.
WARNING!!
ATTENTION!!
AN INSULATED TRANSFORMER SHOULD BE USED DURING
ANY SERVICE TO AVOID POSSIBLE SHOCK HAZARD, BECAUSE OF LIVE CHASSIS.
THE CHASSIS OF THIS RECEIVER IS DIRECTLY CONNECTED
TO THE AC POWER LINE.
AFIN D’ÉVITER TOUT RISQUE D’ÉLECTROCUTION
PR OVENANT D’UN CHÂSSIS SOUS TENSION, UN
TRANSFORMATEUR D’ISOLEMENT DOIT ETRE UTILISÉ LORS
DE TOUT DÉPANNAGE.
LE CHÂSSIS DE CE RÉCEPTEUR EST DIRECTEMENT
RACCORDÉ Á L’ALIMENTATION SECTEUR.
SAFETY-RELATED COMPONENT WARNING !!
ATTENTION AUX COMPOSANTS RELATIFS Á LA
SÉCURITÉ!!
COMPONENTS IDENTIFIED BY A ! MARK ON THE SCHEMATIC
DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE
CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR
AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MAPQUE ! SUR
LES SCHÉMAS DE PRINCIPE, LES VUES EXPLOSÉES ET LES
LISTES DE PIECES SONT D’UNE IMPORTANCE CRITIQUE
POUR LA SÉCURITÉ DU FONCTIONNEMENT. NE LES
REMPLACER QUE PAR DES COMPOSANTS SONY DONT LE
NUMÉRO DE PIÈCE EST INDIQUÉ DANS LE PRÉSENT MANUEL
OU DANS DES SUPPLÉMENTS PUBLIÉS PAR SONY.
TABLE OF CONTENTS
1. Operating Instructions
Operating Instructions ............................................................................................ 1-1
Quick Reference Card .......................................................................................... 1-22
2. Service Informations
2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.
2-8.
2-9.
2-10.
Circuit Boards Location .............................................................................. 2-1
Extension Boards and Flexible Cables ........................................................ 2-1
Cover Removal............................................................................................ 2-2
Front Panel Assy and NF Board Removal .................................................. 2-2
C Board Removal ........................................................................................ 2-3
Optics Unit Assy Removal .......................................................................... 2-3
GA, GBA and GBB Boards Removal ......................................................... 2-4
B, BA and QA Boards Removal ................................................................. 2-4
Lens Removal.............................................................................................. 2-5
Prism Block and In-Polarizer Panel Assy Removal .................................... 2-5
3. Electrical Adjustments
3-1.
3-2
3-3.
3-4.
3-5.
3-6.
VPL-CS1
Preparations ................................................................................................. 3-1
3-1-1. Equipment Required................................................................... 3-1
3-1-2. Optical Unit Adjustment ............................................................ 3-1
3-1-2-1. Mirror Adjustment ....................................................... 3-1
3-1-2-2. Polarizing Plate Adjustment ......................................... 3-1
3-1-3. Factory Mode Setting ................................................................. 3-1
V-COM Adjustment .................................................................................... 3-1
Adjustment Item Initialize Data .................................................................. 3-2
Service Kowhow ......................................................................................... 3-5
3-4-1. After Replacing the Prism Block ............................................... 3-5
3-4-2. After Replacing the Board ......................................................... 3-5
3-4-2-1. When Replacing the BA Board .................................... 3-5
3-4-2-2. When Replacing the C Board ....................................... 3-5
3-4-2-3. When Replacing the Other Board ................................ 3-5
White Balance Adjustment on Servicing .................................................... 3-6
3-5-1. Signal Level Adjustment ............................................................ 3-6
3-5-2. White Balance Adjustment ........................................................ 3-6
3-5-2-1. HIGH Mode of INPUT-A ............................................ 3-6
3-5-2-2. LOW Mode of INPUT-A ............................................. 3-6
3-5-2-3. HIGH Mode of VIDEO ................................................ 3-6
3-5-2-4. LOW Mode of VIDEO................................................. 3-6
Memory ....................................................................................................... 3-7
1
4. Semiconductors
5. Exploded Views
5-1.
5-2.
5-3.
5-4.
5-5.
Cover ........................................................................................................... 5-1
Chassis ......................................................................................................... 5-2
Base ............................................................................................................. 5-3
Optics (1/2) .................................................................................................. 5-4
Optics (2/2) .................................................................................................. 5-5
6. Electrical Parts List
7. Block Diagrams
Overall .................................................................................................................... 7-1
NF, QA ................................................................................................................... 7-2
BA ........................................................................................................................... 7-3
B ............................................................................................................................. 7-4
C, H ......................................................................................................................... 7-6
GA, GAB, GBB ...................................................................................................... 7-8
8. Diagrams
8-1.
8-2.
2
Frame Schematic Diagram
Frame (1/2) ............................................................................................... 8-1
Frame (2/2) ............................................................................................... 8-2
Schematic Diagrams and Printed Wiring Boards ........................................ 8-3
Schematic Diagrams
NF, QA (1/2) ............................................................................................. 8-5
QA (2/2) .................................................................................................... 8-6
BA ............................................................................................................. 8-8
B (1/4) ..................................................................................................... 8-10
B (2/4) ..................................................................................................... 8-11
B (3/4) ..................................................................................................... 8-12
B (4/4) ..................................................................................................... 8-13
C (1/5) .................................................................................................. 8-15
C (2/5) .................................................................................................. 8-16
C (3/5) .................................................................................................. 8-17
C (4/5) .................................................................................................. 8-18
C (5/5) .................................................................................................. 8-19
H .............................................................................................................. 8-21
GA ........................................................................................................... 8-23
VPL-CS1
GBA ........................................................................................................ 8-24
GBB ........................................................................................................ 8-24
Printed Wiring Boards
NF, QA ...................................................................................................... 8-4
BA ............................................................................................................. 8-7
B ................................................................................................................ 8-9
C .............................................................................................................. 8-14
H .............................................................................................................. 8-21
GA ........................................................................................................... 8-22
GBA ........................................................................................................ 8-24
GBB ........................................................................................................ 8-24
VPL-CS1
3
VPL-CS1
4-074-278-11 (1)
LCD Data Projector
GB
Mode d'emploi
FR
Manual de instrucciones
ES
© 1999 Sony Corporation
1-1
This section is extracted
from operation manual.
VPL-CS1
Section 1
Operating Instructions
Operating Instructions
1-2
WARNING
To prevent fire or shock hazard, do
not expose the unit to rain or
moisture.
To avoid electrical shock, do not
open the cabinet. Refer servicing to
qualified personnel only.
This symbol is intended to
alert the user to the presence
of uninsulated “dangerous
voltage” within the
product’s enclosure that may
be of sufficient magnitude to
constitute a risk of electric
shock to persons.
This symbol is intended to
alert the user to the presence
of important operating and
maintenance (servicing)
instructions in the literature
accompanying the
appliance.
For the customers in the USA
following two conditions: (1) This device
may not cause harmful interference, and (2)
this device must accept any interference
received, including interference that may
cause undesired operation.
This equipment has been tested and found to
comply with the limits for a Class B digital
device, pursuant to Part 15 of the FCC
Rules. These limits are designed to provide
reasonable protection against harmful
interference in a residential installation.
This equipment generates, uses, and can
radiate radio frequency energy and, if not
installed and used in accordance with the
instructions, may cause harmful interference
to radio communications. However, there is
no guarantee that interference will not occur
in a particular installation. If this equipment
does cause harmful interference to radio or
television reception, which can be
determined by turning the equipment off and
on, the user is encouraged to try to correct
the interference by one or more of the
following measures:
- Reorient or relocate the receiving antenna.
- Increase the separation between the
equipment and receiver.
- Connect the equipment into an outlet on a
circuit different from that to which the
receiver is connected.
- Consult the dealer or an experienced radio/
TV technician for help.
You are cautioned that any changes or
modifications not expressly approved in this
manual could void your authority to operate
this equipment.
For the customers in Canada
This Class B digital apparatus complies with
Canadian ICES-003.
For the customers in the United
Kingdom
WARNING
THIS APPARATUS MUST BE
EARTHED
IMPORTANT
The wires in this mains lead are coloured in
accordance with the following code:
Green-and-Yellow: Earth
Blue: Neutral
Brown: Live
As the colours of the wires in the mains lead
of this apparatus may not correspond with
the coloured markings identifying the
terminals in your plug proceed as follows:
The wire which is coloured green-andyellow must be connected to the terminal in
the plug which is marked by the letter E or
by the safety earth symbol I or coloured
green or green-and-yellow.
The wire which is coloured blue must be
connected to the terminal which is marked
with the letter N or coloured black. The wire
which is coloured brown must be connected
to the terminal which is marked with the
letter L or coloured red.
Voor de klanten in Nederland
Bij dit product zijn batterijen
geleverd. Wanneer deze leeg
zijn, moet u ze niet
weggooien maar inleveren
als KCA.
The socket-outlet should be installed near
the equipment and be easily accessible.
Declaration of Conformity
Trade Name: SONY
Model No.: VPL-CS1
Responsible Party: Sony Electronics Inc.
Address: 1 Sony Drive, Park Ridge,
NJ.07656 USA
Telephone No.: 201-930-6970
This device complies with Part 15 of the
FCC Rules. Operation is subject to the
VPL-CS1
GB
2
3 GB
VPL-CS1
Table of Contents
Overview
Precautions .........................................6
Troubleshooting ............................... 31
Warning Messages ..................... 33
Caution Messages ...................... 33
Features .............................................. 7
Location and Function of Controls ... 8
Front/Left Side/Bottom ................ 8
Rear/Right Side ............................ 8
Control Panel ..............................10
Connector Panel .........................11
Remote Commander ...................12
Other
Notes on Installation ........................ 34
Unsuitable Installation ............... 34
Unsuitable Conditions ................ 34
Specifications .................................. 35
Index ............................................... 41
Setting Up and Projecting
GB
Installing the Projector .....................14
Connecting the Projector ..................15
Connecting with a Computer ......15
Connecting with a VCR or 15k
RGB/Component
Equipment .......................17
Selecting the Menu Language ..........19
Projecting .........................................21
Adjustments and Settings
Using the Menu
Using the MENU .............................24
The PICTURE CTRL Menu ............25
The INPUT SETTING Menu ...........26
The SET SETTING Menu ...............27
Maintenance
Maintenance .....................................29
Replacing the Lamp ....................29
Cleaning the Air Filter ................30
1-3
5 GB
1-4
B Overview
Precautions
On preventing internal heat buildup
Features
On safety
After you turn off the power with the I / 1
key, do not disconnect the unit from the wall
outlet while the cooling fan is still running.
High portability
On illumination
• To obtain the best picture, the front of the
screen should not be exposed to direct
lighting or sunlight.
• Ceiling-mounted spot lighting is
recommended. Use a cover over
fluorescent lamps to avoid lowering the
contrast ratio.
• Cover any windows that face the screen
with opaque draperies.
• It is desirable to install the projector in a
room where floor and walls are not of
light-reflecting material. If the floor and
walls are of reflecting material, it is
recommended that the carpet and wall
paper be changed to a dark color.
Caution
The projector is equipped with ventilation
holes (intake) on the bottom side and
ventilation holes (exhaust) on left and rear.
Do not block or place anything near these
holes, or internal heat build-up may occur,
causing picture degradation or damage to the
projector.
• Light weight/small size
This projector has been miniaturized to
approx. 2.9 kg (6 lb 6 oz) in weight and
B5-file size through the adoption of a new
retractable mechanism. A carrying handle
and a removable strap are equipped with
the projector, so you can carry it easily
with your computer.
Reduced noise
On cleaning
• To keep the cabinet looking new,
periodically clean it with a soft cloth.
Stubborn stains may be removed with a
cloth lightly dampened with a mild
detergent solution. Never use strong
solvents, such as thinner, benzene, or
abrasive cleansers, since these will
damage the cabinet.
• Avoid touching the lens. To remove dust
on the lens, use a soft dry cloth. Do not use
a damp cloth, detergent solution, or
thinner.
• Clean the filter at regular intervals.
On repacking
• Save the original shipping carton and
packing material; they will come in handy
if you ever have to ship your unit. For
maximum protection, repack your unit as
it was originally packed at the factory.
Because the projector uses a new cooling
mechanism, noise has been reduced.
High brightness, high picture
quality
• High brightness
Adopting the new developed optical
system and the 120 W UHP lamp allows
high brightness (light output 600 ANSI
lumen) and excellent uniformity on the
picture.
• High resolution
Three 0.7-inch, about 480,000 pixel
SVGA panels provide a resolution of 800
× 600 dots for RGB input and 600
horizontal TV lines for video input.
Simple setup, easy presentation
• Simple setup with external equipment
This projector is preset for 37 kinds of
input signals. You can project images from
an external signal source just by
connecting the equipment with the
supplied cable and pushing the APA key.
• Simple Remote Commander with
mouse control functions
You can operate a computer with the
Remote Commander since the unit has a
build-in mouse receiver.
Compatible with USB (Universal
Serial Bus) hub function
Accepts various input signals
• Scan converter loaded
This projector has a build-in scan
converter that converts the input signal
within 800 × 600 dots.
• Compatible input signals
This projector accepts video signals of
composite, S video, and component as
well as 15k RGB, VGA, SVGA, XGA,
and SXGA signals, which all can be
displayed.
• Compatible with six color systems
NTSC, PAL, SECAM, NTSC4.432), PALM, or PAL-N color system can be selected
automatically or manually.
......................................................................
• Windows is a registered trademark of
Microsoft Corporation in the United States
and/or other countries.
• VGA, SVGA, XGA, and SXGA are
registered trademarks of the International
Business Machines Corporation, U.S.A.
• Macintosh is a registered trademark of
Apple Computer, Inc.
• IBM PC/AT is a registered trademark of
International Business Machines
Corporation, U.S.A.
• VESA is a registered trademark of Video
Electronics Standard Association.
• Display Data Channel is a trademark of
Video Electronics Standard Association.
• PC-98 is a trademark of NEC Corporation.
1)The supplied application software and the
USB hub function of this projector are
compatible with Windows 98 preinstall
model.
2)NTSC4.43 is the color system used when
playing back a video recorded on NTSC
on a NTSC4.43 system VCR.
You can connect the projector to USB
equipment, such as a USB mouse, and
VPL-CS1
GB
6
Precautions
Features
7 GB
Overview
• Check that the operating voltage of your
unit is identical with the voltage of your
local power supply.
• Should any liquid or solid object fall into
the cabinet, unplug the unit and have it
checked by qualified personnel before
operating it further.
• Unplug the unit from the wall outlet if it is
not to be used for several days.
• To disconnect the cord, pull it out by the
plug. Never pull the cord itself.
• The wall outlet should be near the unit and
easily accessible.
• The unit is not disconnected to the AC
power source (mains) as long as it is
connected to the wall outlet, even if the
unit itself has been turned off.
• Do not look into the lens while the lamp is
on.
• Do not place your hand or objects near the
ventilation holes. The air coming out is
hot.
• Be careful not to catch your fingers by the
adjuster when you lift up the projector. Do
not push hard on the top of the projector
with the adjuster out.
control the projector by using the supplied
application software from a computer.1)
Using this application software, you can
open a file you want to use for your
presentation with the supplied Remote
Commander.
VPL-CS1
Location and
Function of Controls
2 Front cover
Slide the lock button to open the front
cover. The leg on the bottom of the
projector opens. When projecting the
picture, place the projector on a flat
surface with the leg open.
3 Carrying handle
Pull up the handle from the projector for
carrying.
4 Zoom ring
q f Security lock
Connects to an optional security cable
(Kensington’s).
The security lock corresponds to
Kensington’s MicroSaver Security
System.
If you have any comment, contact:
Kensington
2853 Campus Drive
San Mates, CA 94403
U.S.A.
Tel: 800-535-4242: extension
3348
Overview
Front/Left Side/Bottom
1 Lock button
Adjusts the picture size.
Home page address:
http://www.kensington.com/
5 Focus ring
Adjusts the picture focus.
6 Front remote control detector
(SIRCS receiver)
7 Lens
8 AC IN socket
Connects the supplied AC power cord.
9 Ventilation holes (intake)/air
filter cover (bottom)
Notes
Rear/Right Side
q g Speaker
q h Rear remote control detector
(SIRCS receiver)
q j Leg
q k Connector panel
For details, see “Connector Panel” on
page 11.
q l Ventilation holes (intake)
• Do not place anything near the
ventilation holes as it may cause internal
heat build-up.
• Do not place your hand or objects near
the ventilation holes as it may cause the
air coming out heat build-up.
• To maintain optimal performance, clean
the air filter every 300 hours.
q; Lamp cover (bottom)
qa Ventilation holes (exhaust)
qs Control panel
For details, see “Control Panel” on
page 10.
qd Shoulder strap holder
1-5
GB
8
Location and Function of Controls
Location and Function of Controls
9 GB
1-6
5 Indicators
Control Panel
RESET
POWER
MENU
APA
VOLUME
–
LAMP/COVER
+
FAN/TEMP POWER SAVING ON/STANDBY
1 I / 1 (on/standby) key
Turns on and off the projector when the
projector is in standby mode. The ON/
STANDBY indicator lights in green
when the power is turned on.
When turning off the power, press
the I / 1 key twice following the
message on the screen, or press and hold
the key for about one second.
For details on steps for turning off the
power, see “To turn off the power” on
page 23.
2 INPUT key
Selects the input signal. Each time you
press the key, the input signal switches
between video input and INPUT A
connector.
3 APA (Auto Pixel Alignment) key
Adjusts a picture clearest automatically
while a signal is input from a computer.
4 VOLUME +/– keys
Adjust the volume of the built-in
speakers.
+ : Increases the volume.
– : Decreases the volume.
VPL-CS1
GB
10
Location and Function of Controls
For details on the LAMP/COVER and
the FAN/TEMP indicators, see page 32.
6 ENTER key
Note
Enters the settings of items in the menu
system.
7 Arrow keys (M
M /m
m/<
</,
,)
Select the menu or to make various
adjustments.
8 RESET key
3 MOUSE connector (6-pin)
Resets the value of an item back to its
factory preset value. This key functions
when the menu or a setting item is
displayed on the screen.
9 MENU key
Displays the on-screen menu. Press
again to clear the menu.
Rear side
MOUSE
VIDEO
Connects to the PS/2 mouse port on a
computer via the supplied mouse cable,
to control the mouse function of the
connected computer.
4 USB connector (USB A-plug for
downstream, 4-pin)
Connect to USB equipment such as a
mouse, camera, etc.
5 USB connector (USB B-plug for
upstream, 4-pin)
Connector Panel
AUDIO
If you connect video equipment to both the
S VIDEO and VIDEO jacks, the signal
from the S VIDEO jack is selected. When
projecting the picture via the VIDEO jack,
be sure not to connect a cable to the S
VIDEO jack.
S VIDEO
INPUT A
1 INPUT A connector (HD D-sub
15-pin, female)
Connect to external equipment such as a
computer.
Connects to the monitor output on a
computer using the supplied cable.
When inputting a component or 15k
RGB signal, use an optional cable.
2 Video input connector
Connect to external video equipment
such as a VCR.
• S VIDEO (mini DIN 4-pin):
Connects to the S video output (Y/C
video output) of video equipment.
• VIDEO (phono type): Connects to
the composite video output of video
equipment.
Connect to the USB connector on a
computer. When you connect the
projector to the computer, the projector
recognizes the mouse of the computer
connected to the INPUT A connector
and you can control the mouse function
with the supplied Remote Commander.
The supplied application software can
be installed in the computer attached to
this connector.
6 AUDIO (stereo minijack)
connector
When listening to sound output from the
computer, connect to the audio output of
the computer.
When listening to sound output from the
VCR, connect to the audio output of the
VCR.
This connector functions as the audio
input of the INPUT A, VIDEO and S
VIDEO connectors.
Location and Function of Controls
11 GB
Overview
INPUT
ENTER
• LAMP/COVER: Lights up or flashes
under the following conditions:
– Lights up when the lamp has
reached the end of its life or
becomes a high temperature.
– Flashes when the lamp cover or air
filter cover is not secured firmly.
• FAN/TEMP (Temperature): Lights
up or flashes under the following
conditions:
– Lights up when temperature inside
the projector becomes unusually
high.
– Flashes when the fan is broken.
• POWER SAVING: Lights up when
the projector is in power saving mode.
When POWER SAVING in the SET
SETTING menu is set to ON, the
projector goes into power saving mode
if no signal is input for 10 minutes.
Although the lamp goes out, the
cooling fan keeps running. In power
saving mode, any key does not
function for the first 30 seconds. The
power saving mode is canceled when a
signal is input or any key is pressed.
• ON/STANDBY: Lights up or flashes
under the following conditions:
– Lights in red when a AC power cord
is plugged into a wall outlet. Once in
standby mode, you can turn on the
projector with the I / 1 key.
– Lights in green when the power is
turned on.
– Flashes in green while the cooling
fan runs after the power is turned off
with the I / 1 key. The fan runs for
about 90 seconds after the power is
turned off.
The ON/STANDBY indicator
flashes quickly for the first 30
seconds. During this time, you
cannot turn the power back on with
the I / 1 key.
VPL-CS1
For details, see the README file and
the HELP file supplied with the
application software.
Remote Commander
For details, see “To control the computer
using the supplied Remote Commander” on
page 22.
4 L CLICK key
Functions as the left button on a mouse.
5 R CLICK key
Functions as the right button on a mouse.
6 Joystick
Functions as the mouse of the computer
connected to the unit.
7 Infrared transmitter
To install batteries
1
Push and slide to open the lid, then
install the two size AAA (R03)
batteries (supplied) with the correct
polarity.
R. CLICK
Overview
The keys that have the same names as those
on the control panel function identically.
You can control a connected computer using
the Remote Commander.
Notes on batteries
• Make sure that the battery orientation is
correct when inserting batteries.
• Do not mix an old battery with a new one
or different types of batteries.
• If you do not use the Remote Commander
for a long time, remove the batteries to
avoid damage from battery leakage. If
batteries have leaked, remove them, wipe
and dry the battery compartment, and
replace the batteries with new ones.
Notes on Remote Commander
operation
• Make sure that nothing obstructs the
infrared beam between the Remote
Commander and the remote control
detector on the projector. Direct the
Remote Commander toward the front or
rear remote control detector.
• The operation range is limited. The shorter
the distance between the Remote
Commander and the projector is, the wider
the angle within which the commander can
control the projector becomes.
1
FUNCTION
INPUT
2
Be sure to install
the battery from
the # side.
2
Replace the lid.
1 I / 1 key
2 INPUT key
3 FUNCTION 1, 2 keys
When you have saved a file in the
FUNCTION 1 or 2 key using the
supplied application software, you can
open the file with a press of the
corresponding key.
1-7
GB
12
Location and Function of Controls
Location and Function of Controls
13 GB
1-8
g
p
j
g
Connecting the Projector
Installing the Projector
This section describes how to install the projector.
The distance between the lens and the screen varies depending on the size of
the screen. Use the following table as a guide.
When making connections, be sure to do the following:
• Turn off all equipment before making any connections.
• Use the proper cables for each connection.
• Insert the cable plugs properly; plugs that are not fully inserted often
generate noise. When pulling out a cable, be sure to pull it out from the plug,
not the cable itself.
Setting Up and Projecting
Note
Supplied mouse cables may not work properly according to your computer.
Connecting with a Computer
This section describes how to connect the projector to a computer.
For more information, refer to the computer’s instruction manual.
Distance between the screen and
the center of the lens
Notes
Unit: m (feet)
Screen size
(inches)
40
60
80
100
120
150
Minimum
Distance
1.6
(5.2)
2.4
(7.8)
3.2
(10.5)
4.0
(13.2)
4.9
(15.9)
6.1
(20.0)
Maximum
Distance
2.0
(6.6)
3.1
(10.0)
4.1
(13.5)
5.2
(16.9)
6.2
(20.3)
7.8
(25.5)
Note
You can not install the projector upside down, such as on a ceiling.
VPL-CS1
GB
14
Installing the Projector
• The projector accepts VGA, SVGA, XGA, and SXGA signals. However, we
recommend that you set the output mode of your computer to SVGA mode for the
external monitor.
• If you set your computer, such as a notebook type, to output the signal to both your
computer’s display and the external monitor, the picture of the external monitor may
not appear properly. Set your computer to output the signal to only the external
monitor.
For details, refer to the computer’s operating instructions supplied with your
computer.
• Supplied mouse cables may not work properly according to your computer.
• This projector is compatible with a DDC2B (Digital Data Channel 2B). If your
computer is compatible with a DDC, turn the projector on according to the following
procedures.
1 Connect the projector to the computer by using the supplied HD D-sub 15 pin cable.
2 Turn the projector on.
3 Start the computer.
Connecting the Projector
15 GB
VPL-CS1
To connect an IBM PC/AT compatible computer
When you use a PS/2 mouse port
When you use a USB mouse and USB equipment
Rear side
AUDIO
MOUSE
VIDEO
S VIDEO
INPUT A
Rear side
AUDIO
MOUSE
VIDEO
S VIDEO
INPUT A
Computer
HD D-sub
15-pin cable
(supplied)
Computer
USB equipment
HD D-sub
15-pin cable
(supplied)
to monitor output
Stereo audio connecting cable (not supplied)
to mouse port (PS/2)
to USB connector
Stereo audio connecting cable (not supplied)
to audio output
to audio output
Notes
• When you use the supplied application software, connect your computer
as illustrated above. This application software and the USB hub function
can be used on a computer loaded with Windows 98 preinstall model.
• As the projector recognizes the USB mouse when the computer is
connected to the USB connector, do not connect anything to the PS/2
mouse port.
• Your computer may not start correctly when it has been connected to the
USB connector on the projector via the USB cable. In this case, first
disconnect the USB cable, restart the computer, then connect the
computer to the projector using the USB cable supplied with the
projector.
On the USB hub function
When connecting the projector to a computer by using the USB cable for the
first time, the computer recognizes the following devices automatically.
1 USB hub (general use)
2 USB human interface device (wireless mouse function)
3 USB human interface device (projector control function)
To connect a Macintosh computer
Use an ADP-20 signal adapter (not supplied). In this case, however, you can
not control the mouse of the computer by the Remote Commander.
Connecting with a VCR or 15k RGB/Component Equipment
This section describes how to connect the projector to a VCR and 15k RGB/
component equipment.
For more information, refer to the instruction manuals of the equipment you
are connecting.
To connect a VCR
Rear side
AUDIO
MOUSE
Stereo audio
connecting
cable (not
supplied)
VIDEO
S VIDEO
INPUT A
S-Video cable (not supplied)
Video cable (not supplied)
to audio
output
Excepting these devices above mentioned, the computer recognizes the device
connected to the downstream connector on the projector.
to video to S video
output1) output1)
VCR
1)When both the S VIDEO and VIDEO jacks are connected to the external equipment,
the input signal from the S VIDEO jack is selected.
1-9
GB
16
Connecting the Projector
Connecting the Projector
17 GB
Setting Up and Projecting
PS/2 Mouse cable (supplied)
USB cable A type – B type (supplied)
to monitor output
1-10
To connect a 15k RGB/Component equipment
Selecting the Menu Language
Rear side
AUDIO
MOUSE
VIDEO
S VIDEO
INPUT A
You can select one of seven languages for displaying the menu and other onscreen displays. The factory setting is English.
Stereo audio
connecting
cable (not
supplied)
RESET
3
2
POWER
MENU
15k RGB/Component equipment
1
Notes
Setting Up and Projecting
SMF-402 Signal Cable (not supplied)
3 × phono jack ↔ HD D-sub 15-pin (male)
to RGB/
component
to audio
output
output
INPUT
ENTER
• Set the aspect ratio using ASPECT in the INPUT SETTING menu
APA
according to the input signal.
• When you connect the unit to 15k RGB/component video equipment,
select RGB or component with the INPUT-A setting in the SET
SETTING menu.
• Use the composite sync signal when you input the external sync signal
from 15k RGB/component equipment.
VOLUME
–
LAMP/COVER
+
4,5,6
FAN/TEMP POWER SAVING ON/STANDBY
1
Open the front cover, then plug the AC power cord into a wall outlet.
2
Press the I / 1 key to turn on the projector.
3
Press the MENU key.
The menu appears.
The menu presently selected is shown as a yellow button.
INPUT-A
PICTURE CTRL
CONTRAST:
80
BRIGHT:
50
GAMMA MODE: GRAPHICS
COLOR TEMP: HIGH
VPL-CS1
GB
18
Connecting the Projector
Selecting the Menu Language
19 GB
VPL-CS1
4
Press the M or m key to select the SET SETTING menu, then press the ,
or ENTER key.
The selected menu appears.
Projecting
INPUT-A
SET SETTING
STATUS:
ON
INPUT-A:
RGB
KEYSTONE MEMORY: OFF
DIGITAL KEYSTONE: OFF
LANGUAGE:
ENGLISH
POWER SAVING:
OFF
1
SIRCS RECEIVER: FRONT&REAR
LAMP TIMER:
Press the M or m key to select “LANGUAGE,” then press the , or
ENTER key.
5
6
Rear remote
control detector
RESET
MENU
POWER
INPUT-A
SET SETTING
STATUS:
ON
INPUT-A:
RGB
INPUT
KEYSTONE MEMORY: OFF
ENTER
APA
DIGITAL KEYSTONE: OFF
LANGUAGE:
ENGLISH
POWER SAVING:
OFF
6
2
4
APA key
VOLUME
VOLUME +/–
keys
SIRCS RECEIVER: FRONT&REAR
LAMP TIMER:
Setting Up and Projecting
5
00010h
00010h
LAMP/COVER
FAN/TEMP
DBY
POWER SAVING ON/STAN
ON/STANDBY indicator
Press the M or m key to select a language, then press the < or ENTER
key.
The menu changes to the selected language.
R.CLICK
1
FUNCTION
To clear the menu
Press the MENU key.
The menu disappears automatically if a key is not pressed for one minute.
INPUT
2
2
4
1
Open the front cover, plug the AC power cord into a wall outlet, then
connect all equipment.
The ON/STANDBY indicator lights in red and the projector goes into
standby mode.
2
Press the I / 1 key.
The ON/STANDBY indicator lights in green.
3
4
Turn on the equipment connected to the projector.
Press the INPUT key to select the input source.
To input from
Press INPUT to display
Computer connected to the INPUT A connector
INPUT A
Video equipment connected to the video1) input
connector
VIDEO
1) If you connect to both the S VIDEO and VIDEO jacks, the signal from the S
VIDEO jack is selected.
1-11
GB
20
Selecting the Menu Language
Projecting
21 GB
1-12
5
6
Turn the zoom ring to adjust the size of the picture.
Turn the focus ring to adjust the focus.
To turn off the power
1
Caution
Looking into the lens when projecting may cause injury to your eyes.
Note
To adjust the volume
Press VOLUME +/– keys on the control panel.
Key and joystick
Function
R CLICK (front)
Right button
L CLICK (rear)
Left button
Joystick
Corresponds with the movements of the mouse
Note
Make sure that nothing obstructs the infrared beam between the Remote Commander
and the remoter control detector on the projector.
To get the clearest picture
You can adjust picture quality when projecting a signal from the computer.
1
Project a still picture from the computer.
2
Press the APA key.
“Complete!” appears on the screen when the picture is adjusted properly.
Notes
A message disappears if you press any key except the I / 1 key, or if you do not
press any key for five seconds.
2
Press the I / 1 key again.
The ON/STANDBY indicator flashes in green and the fan continues to run for
about 90 seconds to reduce the internal heat. Also, the ON/STANDBY
indicator flashes quickly for the first 30 seconds. During this time, you will not
be able to turn the power back on with the I / 1 key.
3
Unplug the AC power cord from the wall outlet after the fan stops running
and the ON/STANDBY indicator lights in red.
When you cannot confirm the on-screen message
When you cannot confirm the on-screen message in a certain condition, you can
turn off the power by holding the I / 1 key for about one second.
Note
Do not unplug the AC power cord while the fan is still running; otherwise, the fan will
stop even though the internal heat is still high, which could result in a breakdown of the
projector.
To stow the leg on the bottom
If you are not going to use the projector, close the front cover first and then fold
up the leg on the bottom of the projector manually at the end.
On air filter
To maintain optimal performance, clean the air filter every 300 hours.
• Press the APA key when the full image is displayed on the screen. If there are black
edges around the image, the APA function will not function properly and the image
may extend beyond the screen.
• When you switch the input signal or re-connect a computer, press the APA key again
to adjust the picture again.
• You can cancel the adjustment by pressing the APA key again while “ADJUSTING”
appears on the screen.
• The picture may not be adjusted properly depending on the kinds of input signals.
• Adjust the items in the INPUT SETTING menu when you adjust the picture manually.
VPL-CS1
GB
22
Projecting
Projecting
23 GB
Setting Up and Projecting
To control the computer using the supplied Remote Commander
When you connect an IBM PC/AT compatible to the projector, you can control
the mouse of the computer using the Remote Commander.
The R/L CLICK keys and joystick function as follows.
Press the I / 1 key.
“POWER OFF? Please press I / 1 key again.” appears to confirm that you
want to turn off the power.
VPL-CS1
Using the MENU
To change the menu language, see
“Selecting the Menu Language” on page 19.
1
The menu appears.
The menu presently selected is shown as
a yellow button.
INPUT-A
80
CONTRAST:
BRIGHT:
50
GAMMA MODE: GRAPHICS
COLOR TEMP: HIGH
2
The PICTURE CTRL (control) menu is used
for adjusting the picture.
Items that cannot be adjusted depending on
the input signal are not displayed in the
menu.
For details on the unadjustable items, see
page 38.
To clear the menu
Press the MENU key.
PICTURE CTRL
The PICTURE CTRL
Menu
Use the M or m key to select a menu,
then press the , or ENTER key.
The selected menu appears.
Press the MENU key.
The menu disappears automatically if a key
is not pressed for one minute.
To reset items that have been
adjusted
Press the RESET key.
“Complete!” appears on the screen and the
settings appearing on the screen are reset to
their factory preset values.
Items that can be reset are:
• “CONTRAST,” “BRIGHT,” “COLOR,”
“HUE,” and “SHARP” in the PICTURE
CTRL menu
• “DOT PHASE,” “SIZE,” and “SHIFT” in
the INPUT SETTING menu.
• “DIGITAL KEYSTONE” in the SET
SETTING menu.
When the video signal is input
CONTRAST:
80
BRIGHT:
50
COLOR:
50
HUE:
50
SHARP:
50
D. PICTURE:
OFF
INPUT-A
STATUS:
ON
INPUT-A:
RGB
COLOR TEMP: LOW
AUTO
DIGITAL KEYSTONE: OFF
LANGUAGE:
ENGLISH
POWER SAVING:
OFF
SIRCS RECEIVER: FRONT&REAR
LAMP TIMER:
3
4
1-13
GB
24
000 10h
Select an item.
Use the M or m key to select the item,
then press the , or ENTER key.
Make the setting or adjustment on an
item.
Using the MENU
If no signal is input
If there is no input signal, “NO INPUT–
Cannot adjust this item.” appears on the
screen.
Adjusts the picture sharpness. The higher the
setting, the sharper the picture. The lower
the setting, the softer the picture.
When the RGB signal is input
INPUT-A
PICTURE CTRL
CONTRAST:
80
BRIGHT:
50
GAMMA MODE: GRAPHICS
COLOR TEMP: HIGH
GAMMA MODE
Selects a gamma correction curve.
GRAPHICS: Improves the reproduction of
halftones. Photos can be reproduced in
natural tones.
TEXT: Contrasts black and white. Suitable
for images that contain lots of text.
The settings are automatically stored in the
projector memory.
KEYSTONE MEMORY: OFF
SHARP
Emphasizes the black color.
ON: Emphasizes the black color to produce
a bolder “dynamic” picture.
OFF: Reproduces the dark portions of the
picture accurately, in accordance with
the source signal.
About the memory of the settings
SET SETTING
HUE
Adjusts color tones. The higher the setting,
the picture becomes greenish. The lower the
setting, the picture becomes purplish.
D. (Dynamic) PICTURE
Setting items
Menus
Adjusts color intensity. The higher the
setting, the greater the intensity. The lower
the setting, the lower the intensity.
VIDEO
PICTURE CTRL
COLOR SYS:
COLOR
COLOR TEMP
Menu Items
CONTRAST
Adjusts the picture contrast. The higher the
setting, the greater the contrast. The lower
the setting, the lower the contrast.
BRIGHT
Adjusts the picture brightness. The higher
the setting, the brighter the picture. The
lower the setting, the darker the picture.
Adjusts the color temperature.
HIGH: Makes the white color bluish.
LOW: Makes the white color reddish.
COLOR SYS (System)
Selects the color system of the input signal.
• AUTO: NTSC3.58, PAL, SECAM and
NTSC4.43 (switched automatically)
• PAL-M/N: PAL-M/PAL-N and NTSC3.58
(switched automatically)
Normally, set to AUTO. If the picture is
distorted or colorless, select the color system
according to the input signal.
The PICTURE CTRL Menu
25 GB
Overview
The projector is equipped with an on-screen
menu for making various adjustments and
settings. You can perform all of the menu
operation with the control panel on this unit.
Also, you can change the menu language
displayed in the on-screen menu.
• When changing the adjustment level:
To increase the number, press the M or
, key.
To decrease the number, press the m
or < key.
Press the ENTER key to restore the
original screen.
• When changing the setting:
Press the M or m key to change the
setting.
Press the ENTER or < key to restore
the original screen.
1-14
The INPUT SETTING
Menu
For details on the unadjustable items, see
page 38.
When the video signal is input
VIDEO
INPUT SETTING
ASPECT:
4 : 3
No. 01
VIDEO/60
Memory
No.
Signal
type
When the RGB signal is input
INPUT-A
INPUT SETTING
DOT PHASE:
SIZE H
15
800
SHIFT H
H:200
V:30
SCAN CONV: ON
No. 13
640
480
Memory
No.
Signal
type
MENU Items
DOT PHASE
Adjusts the dot phase of the LCD panel and
the signal input from the INPUT A
connector.
Adjust the picture further for finer picture
after the picture is adjusted by pressing the
APA key.
Adjust the picture to where it looks clearest.
Adjusts the horizontal size of picture input
from the INPUT A connector. The higher
the setting, the larger the horizontal size of
the picture. The lower the setting, the
smaller the horizontal size of the picture.
Adjust the setting according to the dots of
the input signal.
For details on the suitable value for the
preset signals, see page 39.
SHIFT
Adjusts the position of the picture input from
the INPUT A connector. H adjusts the
horizontal position of the picture.V adjusts
the vertical position of the picture. As the
setting for H increases, the picture moves to
the right, and as the setting decreases, the
picture moves to the left.
As the setting for V increases, the picture
moves up, and as the setting decreases, the
picture moves down. Use the < or the ,
key to adjust the horizontal position and the
M and m key for the vertical position.
SCAN CONV (Scan converter)
Converts the signal to display the picture
according to the screen size.
ON: Displays the picture according to the
screen size. The picture will lose some
clarity.
OFF: Displays the picture while matching
one pixel of input picture element to that
of the LCD. The picture will be clear but
the picture size will be smaller.
Note
When SVGA, XGA or SXGA signal is input,
this item will not be displayed.
ASPECT
Sets the aspect ratio of the picture. When
inputting 16:9 (squeezed) signal from
equipment such as a DVD player, set to
16:9.
4:3: When the picture with ratio 4:3 is input.
About the Preset Memory No.
This projector has 37 types of preset data for
input signals for INPUT-A (the preset
memory). When a preset signal is input, the
projector automatically detects the signal
type and recalls the data for the signal from
the preset memory to adjust it to an optimum
picture. The memory number and signal type
of that signal are displayed in the INPUT
SETTING menu. You can also adjust the
preset data through the INPUT SETTING
menu.
This projector has 20 types of user memories
for INPUT-A into which you can save the
setting of the adjusted data for an unpreset
input signal.
When an unpreset signal is input for the first
time, a memory number is displayed as 00.
When you adjust the data of the signal in the
INPUT SETTING menu, it will be
registered to the projector. If more than 20
user memories are registered, the newest
memory always overwrites the oldest one.
See the chat on page 39 to find if the signal
is registered to the preset memory.
Since the data is recalled from the preset
memory about the following signals, you
can use these preset data by adjusting SIZE.
Make fine adjustment by adjusting SHIFT.
Signal
Memory No. SIZE
Super Mac-2
23
1312
SGI-1
23
1320
Macintosh 19"
25
1328
Macintosh 21"
28
1456
Sony News
36
1708
PC-9821
1280 × 1024
36
1600
WS Sunmicro
37
1664
The SET SETTING
Menu
The SET SETTING menu is used for
changing the settings of the projector.
Overview
The INPUT SETTING menu is used to
adjust the input signal.
Items that cannot be adjusted depending on
the input signal are not displayed in the
menu.
SIZE
INPUT-A
SET SETTING
STATUS:
ON
INPUT-A:
RGB
KEYSTONE MEMORY: OFF
DIGITAL KEYSTONE: OFF
LANGUAGE:
ENGLISH
POWER SAVING:
OFF
SIRCS RECEIVER: FRONT&REAR
LAMP TIMER:
000 10h
Menu Items
STATUS (on-screen display)
Sets up the on-screen display.
ON: Shows all of the on-screen displays.
OFF: Turns off the on-screen displays
except for the menus, a message when
turning off the power, and warning
messages.
INPUT-A
Selects the RGB or component signal input
from the INPUT A connector.
Note
If the setting is not correct, “Please check
INPUT-A setting.” appears on the screen and
the color of the picture becomes strange or the
picture is not displayed.
KEYSTONE MEMORY
Memorizes the data adjusted with DIGITAL
KEYSTONE.
Note
When the aspect ratio of input signal is other
than 4:3, a part of the screen is displayed in
black.
VPL-CS1
16:9: When the picture with ratio 16:9
(squeezed) is input.
GB
26
The INPUT SETTING Menu
The SET SETTING Menu
27 GB
VPL-CS1
DIGITAL KEYSTONE
Adjusts trapezoidal distortion of the picture
that may occur depending on the projection
angle.
When the upside of the trapezoid is longer
than the downside
: Sets to a plus
value.
LANGUAGE
Selects the language used in the menu and
on-screen displays. Available languages are:
English, French, German, Italian, Spanish,
Japanese and Chinese.
POWER SAVING
When set to ON, the projector goes into
power saving mode if no signal is input for
10 minutes.
SIRCS RECEIVER
Replacing the Lamp
Indicates the total number of hours for which
the lamp currently used has been operated.
3
When it is time to replace the lamp, replace
the lamp promptly with a new LMP-C120
Projector Lamp.
When replacing the lamp after using
the projector
Turn off the projector, then unplug the
power cord.
Wait for at least an hour for the lamp to cool.
Loosen the screw on the lamp unit
with the Phillips screwdriver. Pull out
the lamp unit by the handle.
Handle
Caution
The lamp becomes a high temperature after
turning off the projector with the I / 1 key. If
you touch the lamp, you may scald your finger.
When you replace the lamp, wait for at least an
hour for the lamp to cool.
1
Place a protective sheet (cloth)
beneath the projector. Turn the
projector over so you can see its
underside.
4
Insert the new lamp all the way in until
it is securely in place. Tighten the
screw. Fold up the handle.
Note
FRONT: Activates the front detector only.
REAR: Activates the rear detector only.
LAMP TIMER
For safety sake, do not loosen any other
screws.
Maintenance
Selects the remote control detectors (SIRCS
receiver) on the front and rear of the
projector.
FRONT & REAR: Activates both the front
and rear detectors.
Note
Maintenance
Be sure that the projector is stable after
turning it over.
2
Open the lamp cover by loosening a
screw with the Phillips screwdriver
(supplied with the LMP-C120
Projector Lamp).
Notes
• Be careful not to touch the glass surface
of the lamp.
• The power will not turn on if the lamp is
not secured properly.
5
1-15
GB
28
The SET SETTING Menu
Close the lamp cover and tighten the
screws.
Maintenance
29
GB
1-16
6
Turn the projector back over.
7
Connect the power cord and turn the
projector to standby mode.
8
3
Remove the air filter cover.
If the projector appears to be operating erratically, try to diagnose and correct the problem
using the following instructions. If the problem persists, consult with qualified Sony personnel.
Press the following keys on the
control panel in the following order
for less than five seconds each:
RESET, <, ,, ENTER.
Power
Symptom
Notes
• Be sure to use the LMP-C120 Projector
Lamp for replacement. If you use lamps
other than LMP-C120, the projector may
cause a malfunction.
• Be sure to turn off the projector and unplug
the power cord before replacing the lamp.
• Do not put your hands into the lamp
replacement spot, or not fall any liquid or
object into it to avoid electrical shock or fire.
Cleaning the Air Filter
1
Turn off the power and unplug the
power cord.
2
Turn the projector over.
4
Remove the dust from the filter with a
vacuum cleaner.
5
Attach the air filter and replace the
cover.
Notes
• If the air filter is excessively dirty, wash it
with mild detergent solution and dry it in a
shaded place. If the dust cannot be removed,
replace the air filter with the supplied new
one.
• Be sure to attach the air filter cover firmly;
the power will not be turned on if it is not
closed securely.
• The air filter has a face and a reverse side.
Place the air filter so that it fits in a notch on
the air filter cover.
Cause and Remedy
The power is not turned on. • The power has been turned off and on with the I / 1 key at a short
interval.
c Wait for about 90 seconds before turning on the power
(see page 23).
• The lamp cover is detached.
c Close the lamp cover securely (see page 29).
• The air filter cover is detached.
c Close the air filter cover securely (see page 30).
Both the LAMP/COVER
• The electrical system breaks down.
and FAN/TEMP indicators
c Consult with qualified Sony personnel.
light up.
Picture
Symptom
Cause and Remedy
No picture.
• Cable is disconnected or the connections are wrong.
c Check that the proper connections have been made
(see page 15).
• Input selection is incorrect.
c Select the input source correctly using the INPUT key
(see page 21).
• The computer signal is not set to output to an external monitor.
c Set the computer signal to output to an external monitor
(see page 15).
• The computer signal is set to output to both the LCD of the
computer and external monitor.
c Set the computer signal to output only to the external monitor
(see page 15).
The picture is noisy.
• Noise may appear on the background depending on the
combination of the numbers of dot input from the connector and
numbers of pixel on the LCD panel.
c Change the desktop pattern on the connected computer.
The picture from INPUT A • Setting for INPUT-A in the SET SETTING menu is incorrect.
connector is colored
c Select RGB or COMPONENT for INPUT-A in the SET
strange.
SETTING menu according to the input signal (see page 27).
“Please check INPUT-A
• Setting for INPUT-A in the SET SETTING menu is incorrect.
setting.” appears in spite of
c Select RGB or COMPONENT for INPUT-A in the SET
inputting the correct signal
SETTING menu according to the input signal (see page 27).
from INPUT A.
On-screen display does not • STATUS in the SET SETTING menu has been set to OFF.
appear.
c Set STATUS in the SET SETTING menu to ON (see page 27).
VPL-CS1
GB
30
Maintenance
Troubleshooting
31 GB
Maintenance
The air filter should be cleaned every 300
hours. When it becomes difficult to remove
the dust from the filter, replace the filter with
a new one.
To clean the air filter, follow the steps
below:
Troubleshooting
VPL-CS1
Symptom
Cause and Remedy
Symptom
Cause and Remedy
Color balance is incorrect.
• Picture has not been adjusted properly.
c Adjust the picture (see page 25).
• Projector is set to wrong color system.
c Set COLOR SYS in the PICTURE CTRL menu to match the
color system being input (see page 25).
The LAMP/COVER
indicator lights up.
• The lamp has reached the end of its life.
c Replace the lamp (see page 29).
• The lamp becomes a high temperature.
c Wait for 90 seconds to cool down the lamp and turn on the
power again (see page 29).
The picture is too dark.
• Contrast or brightness has not been adjusted properly.
c Adjust the contrast or brightness in the PICTURE CTRL menu
properly (see page 25).
The FAN/TEMP indicator
flashes.
• The fan is broken.
c Consult with qualified Sony personnel.
The picture is not clear.
• Picture is out of focus.
c Adjust the focus (see page 22).
• Condensation has occurred on the lens.
c Leave the projector for about two hours with the power on.
The FAN/TEMP indicator
lights up.
• The internal temperature is unusually high.
c Check to see if nothing is blocking the ventilation holes.
The picture appears too
small on the screen.
• SHIFT in the INPUT SETTING menu has not been adjusted
properly.
c Adjust SHIFT in the INPUT SETTING menu properly (see
page 26).
The picture flickers.
• DOT PHASE in the INPUT SETTING menu has not been adjusted
properly.
c Adjust DOT PHASE in the INPUT SETTING menu properly
(see page 26).
Both the LAMP/COVER
• The electrical system breaks down.
and FAN/TEMP indicators
c Consult with qualified Sony personnel.
light up.
Warning Messages
Use the list below to check the meaning of the messages displayed on the screen.
Meaning and Remedy
• Internal temperature is too high.
c Turn off the power.
c Check to see if nothing is blocking the ventilation holes.
Frequency is out of range!
• This input signal cannot be projected as the frequency is out of the
acceptable range of the projector.
c Input a signal that is within the range of the frequency.
• The resolution setting of the output signal of a computer is too
high.
c Set the setting of output to SVGA (see page 15).
Please check INPUT-A
setting.
• You have input RGB signal from the computer when INPUT-A in
the SET SETTING menu is set to COMPONENT.
c Set INPUT-A correctly (see page 27).
Sound
Symptom
Cause and Remedy
No sound.
• Cable is disconnected or the connections are wrong.
c Check that the proper connections have been made (see page
15).
When sound is input
• Monaural sound is being input through the AUDIO connector.
through AUDIO connector,
c Input stereo sound.
sound comes through one
channel only.
Remote Commander
Symptom
Cause and Remedy
The Remote Commander
does not work.
• The Remote Commander batteries are dead.
c Replace with new batteries (see page 12).
• The front/rear remote control detector is near the fluorescent lamp.
c Change the setting of SIRCS RECEIVER in the SET SETTING
menu (see page 28).
The joystick, R CLICK, or • The mouse port on the computer does not recognize the mouse
L CLICK key does not
cable.
function.
c Restart the computer.
Caution Messages
Use the list below to check the meaning of the messages displayed on the screen.
Message
Meaning and Remedy
NO INPUT
• No input signal
c Check connections (see page 15).
Not applicable!
• You have pressed the wrong key.
c Press the appropriate key.
Others
1-17
GB
Symptom
Cause and Remedy
The LAMP/COVER
indicator flashes.
• The lamp cover or the air filter cover is detached.
c Attach the cover securely (see page 29).
32
Troubleshooting
Troubleshooting
33 GB
Maintenance
Message
High temp.!
Lamp off in 1 min.
1-18
Notes on Installation
Unsuitable Installation
Do not install the projector in the following
situations. These installations may cause
malfunction or damage to the projector.
Poorly ventilated
Very dusty
• Avoid installing the unit in a location
where the temperature or humidity is very
high, or temperature is very low.
• To avoid moisture condensation, do not
install the unit in a location where the
temperature may rise rapidly.
VPL-CS1
GB
34
Notes on Installation
Toppling the unit
Avoid using as the unit topples over on its
side. It may cause malfunction.
Projection system
3 LCD panels, 1 lens, projection
system
LCD panel
0.7-inch TFT LCD panel,
1,440,000 pixels (480,000
pixels × 3)
Lens
1.3 times zoom lens
f 28.7 to 37.4 mm/F 1.7 to 2.1
Lamp
120 W UHP
Projection picture size
Range: 40 to 150 inches (diagonal
measure)
Light output ANSI lumen1) 600 lm
Throwing distance (When the SVGA signal is
input)
40-inch: 1580 to 2010 mm
(62 1/4 to 78 25/32 inches)
60-inch: 2390 to 3060 mm
(94 1/8 to 120 1/2 inches)
80-inch: 3210 to 4100 mm
(126 1/2 to 161 1/2 inches)
100-inch: 4030 to 5150 mm
(158 11/16 to 202 7/8 inches)
120-inch: 4850 to 6200 mm
(191 to 244 1/8 inches)
150-inch: 6080 to 7780 mm
(239 1/2 to 306 3/8 inches)
1) ANSI lumen is a measuring method of
American National Standard IT 7.228.
Electrical characteristics
Tilting the unit
Do not install the unit other than on the floor.
Avoid using as the unit tilts upward or
downward. These installation may cause
malfunction.
Color system NTSC3.58/PAL/SECAM/
NTSC4.43/PAL-M/PAL-N
system, switched automatically/
manually
Resolution
600 horizontal TV lines (Video
input)
800 × 600 dots (RGB input)
Acceptable computer signals
fH: 15 to 91 kHz
fV: 43 to 85 Hz
Speaker
Stereo speakers system, 36 mm
(1 7/16 inches) diameter,
max. 0.5 W × 2
Specifications
35 GB
Other
Highly heated and humid
Do not use the projector under the following
conditions.
Specifications
Optical characteristics
Avoid using something to cover over the
ventilation holes (exhaust/intake);
otherwise, the internal heat may build up.
Unsuitable Conditions
• Allow adequate air circulation to prevent
internal heat build-up. Do not place the
unit on surfaces (rugs, blankets, etc.) or
near materials (curtains, draperies) that
may block the ventilation holes. When the
internal heat builds up due to the block-up,
the temperature sensor will function with
the message “High temp.! Lamp off in 1
min.” The power will be turned off
automatically after one minute.
• Leave space of more than 30 cm (11 7/8
inches) around the unit.
• Be careful that the ventilation holes may
inhale tininess such as a piece of paper.
Blocking the ventilation holes
Avoid installing the unit in a location where
there is a lot of dust; otherwise, the air filter
will be obstructed. The dust blocking the air
through the filter may cause raising the
internal heat of the projector. Clean it up
periodically.
VPL-CS1
General
Video input
277 × 70 × 214 mm (11 × 2 7/8 ×
8 1/2 inches) (w/h/d) (with the
front cover closed, without the
projection parts)
Mass
Approx. 2.9 kg (6 lb 6 oz)
(without strap)
Power requirements
AC 100 to 240 V, 1.9–0.8A,
50/60 Hz
Power consumption
Max. 190 W
(Standby mode: 4.2 W)
Heat dissipation
648.4 BTU
Operating temperature
0°C to 35°C (32°F to 95°F)
Operating humidity
35% to 85% (no condensation)
Storage temperature
–20°C to 60°C (–4°F to 140°F)
Storage humidity
10% to 90%
Supplied accessories
Remote Commander RM-PJM1
(1)
Size AAA (R03) batteries (2)
HD D-sub 15 pin (2 m) (1)
PS/2 Mouse Cable (2 m) (1)
USB cable A type – B type (1)
Application software (1)
Carrying case (1)
AC power cord (1)
Air filter (for replacement) (1)
Operating Instructions (1)
Quick Reference Card (1)
VIDEO: phono type
Composite video: 1 Vp-p ±2 dB
sync negative (75 ohms
terminated)
S VIDEO: Y/C mini DIN 4-pin
type (male)
Y (luminance): 1 Vp-p ±2 dB
sync negative (75 ohms
terminated)
C (chrominance): burst
0.286 Vp-p ±2 dB (NTSC)
(75 ohms terminated),
burst 0.3 Vp-p ±2 dB (PAL)
(75 ohms terminated)
INPUT A:
HD D-sub15-pin (female)
Analog RGB/component:
R/R-Y: 0.7 Vp-p ±2 dB
(75 ohms terminated)
G: 0.7 Vp-p ±2 dB
(75 ohms terminated)
G with sync/Y: 1 Vp-p ±2 dB
sync negative
(75 ohms terminated)
B/B-Y: 0.7 Vp-p ±2 dB
(75 ohms terminated)
SYNC/HD:
Composite sync input: 1-5 Vp-p
high impedance, positive/
negative
Horizontal sync input: 1-5 Vp-p
high impedance, positive/
negative
VD:
Vertical sync input: 1-5 Vp-p
high impedance, positive/
negative
MOUSE:
6-pin (female)
(For details, see “Input signals
and adjustable/setting items”
on page 38.)
AUDIO:
Stereo minijack
500 mVrms, impedance more
than 47 kilohms
USB hub:
Up (B type: female) × 1
Down (A type: female) × 1
Safety regulations:
UL1950, CSA No. 950, FCC Class
B, IC Class B
NEMKO EN60950, CE, C-Tick,
CCIB
1-19
GB
36
Specifications
Dimensions
Some of the items may not be available in some
areas. For details, please consult your nearest
Sony office.
1) VPS-50C may not be available in some areas.
For details, please consult your nearest Sony
office.
Pin assignment
INPUT A connector (HD D-sub 15-pin,
female)
1
R/R-Y
9
N.C.
2
G/Y
10
GND
3
B/B-Y
11
GND
4
GND
12
N.C.
5
GND
13
HD/C.Sync
6
GND (R)
14
VD
7
GND (G)
15
N.C.
8
GND (B)
Other
Input/Output
MOUSE connector (6-pin, female)
6 5 4
3 2 1
Design and specifications are subject to change
without notice.
1
DATA
Optional accessories
2
N.C.
Projector Lamp LMP-C120 (for replacement)
Signal Cable SMF-402 (HD D-sub 15-pin
(male) y 3 × phono type
(male))
Monitor Cable SMF-410 (HD D-sub 15 pin
(male) y HD D-sub 15 pin
(male))
Signal Adapter
ADP-20 (Macintosh y HD Dsub 15-pin)
Screens
50-inch Portable Screen
VPS-50C1)
100-inch Flat Screen
VPS-100FH
120-inch Flat Screen
VPS-120FH
3
GND
4
+5V
5
CLK
6
N.C.
Specifications
37 GB
1-20
Input signals and adjustable/
setting items
Preset signals
PICTURE CTRL menu
Item
Input signal
Video
or S
video
(Y/C)
Com- RGB B&W
ponent
fH (kHz) fV (Hz)
Video 60 Hz
15.734
Video 50 Hz
15.625
50.000
3
15k RGB/Component 60 Hz
15.734
59.940
S on G/Y or
Composite Sync
4
15k RGB/Component 50 Hz
15.625
50.000
S on G/Y or
Composite Sync
640 × 350
z
z
z
z
z
z
6
–
7
–
8
z
z
z
HUE
–
–
–
(NTSC
3.58/
4.43
only)
SIZE
1
z
COLOR
Sync
2
CONTRAST z
BRIGHT
59.940
VGA mode 1
31.469
70.086
H-pos, V-neg
800
VGA VESA 85 Hz
37.861
85.080
H-pos, V-neg
832
PC-9801 Normal
24.823
56.416
H-neg, V-neg
848
9
VGA mode 2
31.469
70.086
H-neg, V-pos
800
10
VGA VESA 85 Hz
37.861
85.080
H-neg, V-pos
832
11
640 × 400
640 × 480
VGA mode 3
31.469
59.940
H-neg, V-neg
800
z
z
–
z
12
Macintosh 13"
35.000
66.667
H-neg, V-neg
864
D. PICTURE z
z
–
z
13
VGA VESA 72 Hz
37.861
72.809
H-neg, V-neg
832
GAMMA
MODE
–
–
z
–
14
VGA VESA 75 Hz
37.500
75.000
H-neg V-neg
840
15
VGA VESA 85 Hz
43.269
85.008
H-neg V-neg
832
COLOR
TEMP
z
SHARP
z
z
–
z
z
–
16
800 × 600
SVGA VESA 56 Hz 35.156
56.250
H-pos, V-pos
1024
17
SVGA VESA 60 Hz 37.879
60.317
H-pos, V-pos
1056
1040
18
SVGA VESA 72 Hz 48.077
72.188
H-pos, V-pos
– : Not adjustable/cannot be set
19
SVGA VESA 75 Hz 46.875
75.000
H-pos, V-pos
1056
INPUT SETTING menu
20
SVGA VESA 85 Hz 53.674
85.061
H-pos, V-pos
1048
z : Adjustable/can be set
Item
Input signal
Video Comor S
ponent
video
(Y/C)
RGB
DOT
PHASE
–
–
z
SIZE
–
–
z
SHIFT
SCAN
CONV
–
–
–
–
z
z
z : Adjustable/can be set
ASPECT
– : Not adjustable/cannot be set
VPL-CS1
38
Specifications
z
z
B&W
–
21
832 × 624
Macintosh 16"
49.724
74.550
H-neg, V-neg
1152
22
1024 × 768
XGA VESA 43 Hz
35.522
43.479
H-pos, V-pos
1264
23
XGA VESA 60 Hz
48.363
60.004
H-neg V-neg
1344
24
XGA VESA 70 Hz
56.476
70.069
H-neg V-neg
1328
25
XGA VESA 75 Hz
60.023
75.029
H-pos, V-pos
1312
26
XGA VESA 85 Hz
68.677
84.997
H-pos, V-pos
1376
27
SXGA VESA 70 Hz 63.995
70.016
H-pos, V-pos
1472
–
28
SXGA VESA 75 Hz 67.500
75.000
H-pos, V-pos
1600
–
29
SXGA VESA 85 Hz 77.487
85.057
H-pos, V-pos
1568
Sunmicro LO
61.795
65.960
H-neg, V-neg
1504
Sunmicro HI
30
–
1152 × 864
–
z
1152 × 900
31
32
33
1280 × 960
71.713
76.047
H-neg, V-neg
1472
SXGA VESA 60 Hz 60.000
60.000
H-pos, V-pos
1800
SXGA VESA 75 Hz 75.000
75.000
H-pos, V-pos
1728
Specifications
Other
COLOR SYS z
GB
Memory Preset signal
No.
39 GB
VPL-CS1
Memory Preset signal
No.
1280 × 1024
34
fH (kHz) fV (Hz)
Sync
SIZE
Index
SXGA VESA 43 Hz 46.433
43.436
H-pos, V-pos
1696
35
SGI-5
53.316
50.062
S on G
1680
A
36
SXGA VESA 60 Hz 63.974
60.013
H-pos, V-pos
1696
37
SXGA VESA 75 Hz 79.976
75.025
H-pos, V-pos
1688
38
SXGA VESA 85 Hz 91.146
85.024
H-pos, V-pos
1296
Adjusting
memory of the settings 24
the picture .............22, 25
the picture size/shift ....26
Air filter ..........................30
ASPECT .........................26
Warning on power connection
Use a proper power cord for your local power supply.
Plug type
B
The United States,
Canada
Continental
Europe
UK, Ireland,
Australia,
Newzealand
Japan
VM0233
YP-12A
— 1)
VM1296
290B
Female end
VM0089
386A
YC-13B
VM0310B
Cord type
SJT
SJT
H05VV-F
N13237/CO-228 HVCTF
Rated Voltage & Current
10A/125V
10A/125V
10A/250V
10A/250V
13A/125V
Safety approval
UL/CSA
UL/CSA
VDE
VDE
DENTORI
VM10505
1) Note: Use an appropriate rating plug which is applied to local regulations.
Battery
installation ..................12
notes ............................13
BRIGHT .........................25
G
L
Lamp replacement ..........29
LAMP TIMER ...............28
LANGUAGE .................28
selecting the menu
language ..............19
Location and function of
controls
connector panel ..........11
control panel ...............10
front/left/bottom side ....8
rear/right side ................8
Remote Commander ...12
Menu
clearing the menu
display .................24
INPUT SETTING
menu ...................26
PICTURE CTRL
menu ...................25
SET SETTING menu .27
using the menu ...........24
Message
caution ........................33
warning .......................33
Mouse cable
connection ..................17
pin assignment ............37
Mouse connector ............11
pin assignment ............37
GAMMA MODE ...........25
O
H
Optional accessories .......36
HUE ................................25
P
I
PICTURE CTRL menu ..25
Pin assignment ...............37
Power
turn on ........................21
POWER SAVING ....10, 28
Precautions .......................6
INPUT A connector .......11
pin assignment ............37
INPUT SETTING menu .26
INPUT-A ........................27
Installation examples ......14
notes ............................34
unsuitable conditions ..34
1-21
Specifications
Remote Commander
battery installation ......12
location and function of
controls ............... 12
Remote control detector
front ..............................8
rear ...............................9
setting ......................... 28
Reset
resetting the item ........24
resttable items .............24
S
SCAN CONV (Scan
converter) ................ 26
Screen size ............... 14, 35
SET SETTING menu .....27
SHARP ........................... 25
SHIFT ............................ 26
SIRCS RECEIVER 8, 9, 28
SIZE ...............................26
Specifications ................. 35
STATUS (on-screen
display) ................... 27
Supplied accessories ......36
T
Troubleshooting .............31
U
USB connector .........11, 16
V
Ventilation holes
exhaust ..........................8
intake ........................ 8, 9
Index
41 GB
Other
Carrying handle ................8
COLOR ..........................25
COLOR SYS (System) ...25
COLOR TEMP ...............25
Connections
component equipment 17
computer .....................15
VCR ............................17
CONTRAST ...................25
D. (Dynamic) PICTURE 25
DIGITAL KEYSTONE ..28
DOT PHASE ..................26
40
R
KEYSTONE MEMORY 27
M
C
D
GB
K
1-22
4-074-279-01 (1)
● When you use a PS/2 mouse / Lorsque vous utilisez une souris PS/2 / Si utiliza un ratón
PS/2 / Wenn Sie eine PS/2-Maus verwenden / Quando si utilizza un mouse PS/2
Quick Reference Card / Carte de référence rapide /Tarjeta de
referencia rápida / Kurzreferenz / Scheda di riferimento rapido
AUDIO
MOUSE
VIDEO
S VIDEO
INPUT A
VPL-CS1
Sony Corporation © 1999 Printed in Japan
B
Connections / Connexions / Conexiones / Anschlüsse /
Collegamenti
MONITOR OUT
MOUSE
D
A*
AUDIO OUT
A Stereo audio connecting cable / Câble de connexion audio stéréo / Cable de conexión de audio estéreo / StereoAudioverbindungskabel / Cavo di collegamento audio stereo
B HD D-sub 15-pin cable / Câble HD D-sub à 15 broches / Cable HD D-sub 15 pines / 15poliges D-Sub-Kabel hoher
Dichte / Cavo HD D-sub a 15 piedini
C USB cable / Câble USB / Cable USB / USB-Kabel / Cavo USB
D Mouse cable / Câble de souris / Cable de ratón / Mauskabel / Cavo del mouse
E S-video cable / Câble S-vidéo / Cable de vídeo S / S-Videokabel / Cavo S-Video
F Video cable / Câble vidéo / Cable de vídeo / Videokabel / Cavo video
G Connect another USB equipment / Raccordez un autre appareil USB / Conexión de otro equipo USB /
Anschließen eines anderen USB-Geräts / Collegare un altro apparecchio USB
Connecting a VCR / Raccordement à un magnétoscope / Conexión con una
vídeograbadora / Anschließen an einen Videorecorder / Collegamento a un
videoregistratore
F*
E*
S VIDEO
OUT
AUDIO
MOUSE
VIDEO
S VIDEO
VIDEO
OUT
AUDIO
OUT
INPUT A
Connecting a computer / Raccordement à un ordinateur / Conexión con ordenador /
Anschließen an einen Computer / Collegamento a un computer
● When you use a USB mouse and USB equipment / Lorsque vous utilisez une souris USB
* not supplied / non fourni / no suministrado / nicht mitgeliefert / non in dotazione
et un appareil USB / Si utiliza un ratón USB y un equipo USB / Wenn Sie eine USB-Maus
und ein USB-Gerät verwenden / Quando si utilizza un mouse USB e un apparecchio USB
Projection Distances / Distances de projection / Distancias de
proyección / Projektionsentfernungen / Distanze di proiezione
AUDIO
MOUSE
VIDEO
S VIDEO
INPUT A
Screen size(inchies) / Taille de l’écran (pouces) / Tamaño de la
pantalla (pulgadas) / Projektions-schirmgröße (Zoll) / Dimensione
schermo (pollici)
G
B
C
A*
MONITOR OUT
USB
AUDIO OUT
Distance (m (feet)) / Distance (m (pieds))/ Distancia (m (pies)) /
Abstand (m) / Distanza (m)
40
1.6–2.0 (5.2–6.6)
60
2.4–3.1 (7.8–10.0)
80
3.2–4.1 (10.5–13.5)
100
4.0–5.2 (13.2–16.9)
120
4.9–6.2 (15.9–20.3)
150
6.1–7.8 (20.0–25.5)
VPL-CS1
VPL-CS1
Basic Operation / Opération de base / Operación básica /
Grundfunktion / Operazione di base
RESET
MENU
POWER
INPUT
ENTER
APA
VOLUME
LAMP/COVER
FAN/TEMP
English
2
4
1
APA
NDBY
POWER SAVING ON/STA
2
3
4
5
Open the front cover, plug the AC power cord
into the wall outlet, then connect all
equipment.
Press the I / u key to turn on the projector.
Turn on equipment connected to the
projector.
Press the INPUT key to select “INPUT-A” or
“VIDEO”.
Turn the zoom ring to adjust the size of the
picture, and then turn the focus ring to adjust
the focus.
To adjust the picture of computer
automatically
Press the APA (Auto Pixel Alignment) key.
5
1
Français
1
2
3
4
5
Ouvrez le volet frontal, branchez le câble
d'alimentation sur une prise murale et
raccordez ensuite tous les appareils.
Appuyez sur la touche I / u pour mettre le
projecteur sous tension.
Mettez sous tension l’appareil raccordé au
projecteur.
Appuyez sur la touche INPUT pour
sélectionner “ENT.A” ou “VIDEO”.
Tournez la bague de mise au point pour régler
la mise au point de l'image optimale, et
ensuite la bague de zoom pour régler la taille
de l'image.
Pour régler l’image d’un ordinateur
automatiquement
Appuyez sur la touche APA (Auto Pixel
Alignment).
R.CLICK
I/1
1
FUNCTION
2
INPUT
2
4
Español
1
2
3
4
5
Abra la tapa frontal, enchufe el cable de
alimentación de CA en la toma mural y, a
continuación, conecte todo el equipo.
Pulse la tecla I / u para encender el
proyector.
Encienda el equipo conectado al proyector.
Pulse la tecla INPUT para ajustar “ENTRAD
A” o “VIDEO”.
Gire el anillo de enfoque para ajustar el
enfoque y, a continuación, gire el anillo de
zoom para ajustar el tamaño de la imagen.
Para ajustar la imagen del ordenador
automáticamente
Pulse la tecla APA (Auto Pixel Alignment).
Deutsch
1
2
3
4
5
Öffnen Sie die Abdeckung vorn, stecken Sie
das Netzkabel in die Steckdose, und schließen
Sie alle Geräte an.
Schalten Sie den Projektor mit der Taste I / u
ein.
Schalten Sie die an den Projektor
angeschlossenen Geräte ein.
Wählen Sie mit der Taste INPUT die
Eingangsquelle „EING.A“ oder „VIDEO“
aus.
Stellen Sie durch Drehen des Fokussierrings
den Fokus und durch Drehen des Zoom-Rings
die Größe des Bildes ein.
Zum automatischen Einstellen des Bildes
des Computers
Drucken Sie die Taste APA (Auto Pixel
Alignment).
Italiano
1
2
3
4
5
Aprire il coperchio anteriore, inserire
l'alimentatore CA nella presa a muro, quindi
collegare tutti gli apparecchi.
Premere il tasto I / u per accendere il
proiettore.
Accendere l’apparecchio collegato al
proiettore.
Premere il tasto INPUT per selezionare
“INGRE A“ o “VIDEO”.
Per regolare la messa a fuoco, ruotare il
regolatore apposito, quindi ruotare il
regolatore dello zoom per regolare le
dimensioni dell'immagine.
Per regolare l’immagine da un computer
automaticamente
Premere il tasto APA (Auto Pixel Alignment).
1-23
Section 2
Service Informations
2-1. Circuit Boards Location
C
BA
B
NF
QA
H
GBA
GA
GBB
2-2. Extension Boards and Flexible Cables
X1 (A-1391-009-A)
For : QA, B Boards
X3 (A-1391-011-A)
For: B, C Boards
XC (A-1391-008-A)
For: C Board
50P (1-900-251-17)
For: X3, X4
X2 (A-1391-010-A)
For: QA, B Boards
X4 (A-1391-024-A)
For: B, C Boards
32P (1-900-251-18)
For: B Board
24P (1-900-251-19)
For: XC
VPL-CS1
2-1
2-3. Cover Removal
2 Top cover
S holder
S holder
Two strap houses
CN001
3 Side cover
CN814
1Six shafts
2-4. Front Panel Assy and NF Board Removal
4 Lamp power
6 Screw (+BVTP3 x 10)
CN806
2P
7 NF board
CN071
1 Four screws (+PS2 x 8)
Unhook
the two
snaps.
2 Lock switch
5 Front panel assy
3 Front cover
2-2
VPL-CS1
2-5. C Board Removal
1 Screw (+PS3 x 5)
2 Earth spring(CT)
CN811
CN812
CN813
CN803
3 C board
CN807
CN802
CN403
2-6. Optics Unit Assy Removal
6 Two screws (+P4 x 8)
• Remove the C Board (Refer to 2-5.).
7 Optics unit assy
4 Lamp
5 Screw (+P4 x 8)
3 Screw (M3)
2 Lamp door
1 Screw (M3)
VPL-CS1
2-3
2-7. GA, GBA and GBB Boards Removal
• Remove the C Board (Refer to 2-5.).
• Remove the optics unit assy (Refer to 2-6.).
9 GBA board
CN671
CN707
0 GBB board
6 Two screws (+PS3 x 5)
CN605
CN702
8 GA board
4 Lamp house
3 Fan
1 Screws (+BTP3 x 8)
2 Two screws (FAN)
7 Front chassis
5 Screw (+P4 x 8)
2-8. B, BA and QA Boards Removal
• Remove the C Board (Refer to 2-5.).
• Remove the optics unit assy (Refer to 2-6.).
7 B board
4 Two screws
CN402
2 Two screws (+PS3 x 5)
CN401
1 BA board
5 Two screws (+PS2 x 8)
CN201
6 Plate(QA)
CN101
CN102
2-4
3 QA board
VPL-CS1
2-9. Lens Removal
2 Lens
1 Two screws (+P4 x 8)
2-10. Prism Block and In-Polarizer Panel Assy Removal
• Remove the C Board (Refer to 2-5.).
• Remove the Optics Unit Assy (Refer to 2-6.).
Use extreme care not to touch the glass section of prism,
LCD, and conductive section of the flexible cable in particular.
5 Screw (+B2.5)
2 Prism block
3 Screw (+B2.5)
Hold with
fingers.
6 In-polarizer panel
(G)assy
4 In-polarizer panel
(R)assy
7 Screw (+B2.5)
8 In-polarizer panel
(B)assy
1 Two screw (+PSW3 x 8)
VPL-CS1
2-5
Section 3
Electrical Adjustments
3-1. Preparations
3-1-2-2.Polarizing Plate Adjustment
3-1-1. Equipment Required
1. Attach the extension cable and the extension flexible
cable to the C board, and input the RGB all black
(SVGA 0 IRE Flat Field) signal.
2. Move the red, green, and blue polarizing plates
gradually to adjust the black level.
3. Secure the fixing screws using the screwdriver.
. Oscilloscope
Tektronix 2465 or equivalent
(bandwidth: 350 MHz or more)
. NTSC, PAL, SECAM component signal generator
Tektronix TG2000 + AVG1 (optional module) + AWVG1
(optional module) or equivalent
. VG (Programmable video signal generator)
VG814 or equivalent
. Digital voltmeter
Advantest TR6845 or equivalent
. Luminance meter
Note:
Perform the following adjustments at least 5
minutes after turning on the power.
3-1-2. Optical Unit Adjustment
Note: When tightening the six fixing screws, be sure to
push the polarizing plate toward the radiating side.
3-1-3. Factory Mode Setting
1. Make sure that the STATUS in the menu is ON.
2. Exit the menu.
3. Press the keys in the following ORDER:
“ENTER” → “ENTER” → “LEFT” → “ENTER”
4. The message “Do you wish to enter into the
FACTORY MODE?” will be displayed.
5. Select YES.
Drive the cooling fan and turn on the lamp.
3-1-2-1. Mirror Adjustment
3-2. V-COM Adjustment
Set the screen size to 80-inch at the wide-end.
1. Set the unit in green-only.
2. Adjust the blanking sections at the top, bottom, left,
and right for minimum by moving the adjusting plate
of the G-channel mirror (OPT).
3. Tighten the adjusting plate fixing screws.
4. Set the unit in cyan.
5. Adjust the blanking sections at the top, bottom, left,
and right for minimum by moving the adjusting plate
of the B-channel mirror (OPT), and then maximize the
intensity of the blue.
6. Tighten the adjusting plate fixing screws.
7. Set the unit in all white.
8. Adjust the blanking sections at the top, bottom, left,
and right for minimum by moving the adjusting plate
of the R-channel’s first mirror (OPT), and then
maximize the intensity of the red.
9. Tighten the adjusting plate fixing screws.
10. Secure the six adjusting plate fixing screws using a
torque screwdriver.
Tightening torque: 8 kgf/cm
11. Make sure that the deviation of the lighting range is
within the specific range.
1. Input the green-only 1H inverted signal to INPUT-A.
2. Set the CONTRAST to 50 and BRIGHT to 50.
3. Set the screen to G VCOM adjustment of “Device
Adjust.”
Adjust the G VCOM so that the flicker on the screen is
minimum.
4. Input the red-only and blue-only 1H inverted signal
respectively and adjust R VCOM and B VCOM
respectively so that the flicker becomes minimum.
5. Save the value adjusted.
VPL-CS1
3-1
3-3. Adjustment Item Initialize Data
Memory Name
Menu Title
Item Name
SET
MEMORY
CH MEMORY
VIDEO
INPUT-A
80
80
BRIGHT
50
50
COLOR
50
50
HUE
50
50
SHARP
50
50
D.PICTURE
OFF
OFF
COLOR TEMP
LOW
HIGH
COLOR SYS
AUTO
-
-
GRAPHICS
PICTURE CTRL CONTRAST
GAMMA MODE
INPUT SETTING ASPECT
SET SETTING
*
SHIFT
*
SCAN CONV
ON (*)
DOT PHASE
15 (*)
STATUS
ON
INPUT-A
RGB
KEYSTONE MEMORY
OFF
DIGITAL KEYSTONE
OFF
POWER SAVING
SIRCS RECEIVER
W/B MEMOR
VIDEO VIDEO
RGB
HIGH
LOW
HIGH
RGB
LOW
4 : 3 (*)
SIZE H
LANGUAGE
INFORMATION
STATUS
MEMORY
ENGLISH
OFF
FRONT&REAR
LAMP TIMER
INDICATION ONLY
fH
INDICATION ONLY
fV
INDICATION ONLY
ROM Ver
INDICATION ONLY
OPERATION TIMER
INDICATION ONLY
PREVIOUS LAMP TIMER INDICATION ONLY
W/B ADJUST
GAIN R
64
64
64
64
GAIN G
64
60
64
60
GAIN B
64
60
64
60
BIAS R
0
0
0
0
BIAS G
0
0
0
0
BIAS B
0
0
0
0
*:
DOT PHASE, SIZE H, SHIFT H/V, SCAN CONV, ASPECT, and BLANKING in the “INPUT SETTING” menu have an initial value
respectively in accordance with the input signal (PRESET MEMORY No.).
Note :
There are nonadjustable items in accordance with the input signal.
3-2
VPL-CS1
Memory Name
Menu Title
RGB MTRX/
Item Name
SET
MEMORY
CHROMA MEMORY
NT358,NT443
PAL,PALM/N
B&W60
SECAM,B&W 50
YUV
Reso
Memory
Status
Memory
Remarks
CONTRAST
49
47
47
BRIGHT
35
35
35
SUB HUE
7
8
7
SUB BRT
7
7
7
R-Y/R
12
11
11
R-Y/B
14
12
13
G-Y/R
9
7
5
G-Y/B
6
6
5
VIDEO CON
9
12
7
VIDEO COL
6
9
7
YUV CON
7
7
9
YUV COL
7
7
7
SUB SHP
2
2
1
Fixed Value
SHP FO
3
3
1
Fixed Value
PRE OVER
0
0
2
Fixed Value
NR LVL
2
2
0
Fixed Value
CEC LVL
2
2
2
Fixed Value
Fixed Value
Fixed Value
DMIC PIC
2
Fixed Value
DCOM/
VENH
0
Fixed Value
CHROMA/
PAL DVD
Non Adjustable
Fixed Value
Y-OUT LVL
15
C-OUT LVL
35
Y-DL
8
Fixed Value
S B-Y ADJ
0
Fixed Value
S R-Y ADJ
3
Fixed Value
S-INHBT
0
Fixed Value
S-ID
0
Fixed Value
S GP
0
Fixed Value
S V-ID
0
Fixed Value
BELL f0
0
Fixed Value
BELL/HPF
0
Fixed Value
SHP GAIN
12
12
12
Fixed Value
SHIP EQ
0
0
0
Fixed Value
SHIP F0
2
2
2
Fixed Value
*:
DOT PHASE, SIZE H, SHIFT H/V, SCAN CONV, ASPECT, and BLANKING in the “INPUT SETTING” menu have an initial value
respectively in accordance with the input signal (PRESET MEMORY No.).
** :
It differs in accordance with the resolution of the input signal.
Note : There are nonadjustable items in accordance with the input signal.
VPL-CS1
3-3
Memory Name
Menu Title
Item Name
SET
MEMORY
CHROMA MEMORY
NT358,NT443
PAL,PALM/N
B&W60
P. DRV/
VCOM G
143
VCOM R
182
VCOM B
187
SIG CEN
120
SID LVL
91
PRG LVL
SH/
V AMP
SC/
0
INSTA DIR-CNT
0
SH 1
4
SH 2
67
Remarks
Fixed Value
CONT
105
Fixed Value
SUB CONT R
128
Fixed Value
SUB CONT G
128
Fixed Value
SUG CONT B
128
Fixed Value
BRT
161
Fixed Value
HALFTONE BRT
1
GAMMA ON
1
0 (Non memory)
VINIT EVEN
**
Fixed Value
VINIT ODD
**
Fixed Value
2 (**)
Fixed Value
SHOGA
0
UNSYNCHRO IFV
Fixed Value
0 (*)
APA SH LVL
Non Adjustable
Fixed Value
SHIFT SH LVL
Non Adjustable
Fixed Value
VCO
CP
OTHER/
Status
Memory
SECAM, B&W 50
EDMOD
PLL/
Reso
Memory
125
INSTA DOWN
FREEZE
APA/
YUV
0 (*)
Fixed Value
*
Fixed Value
TENP LAMP
Non Adjustable
Fixed Value
TENP PANEL
Non Adjustable
Fixed Value
ZOOM
0(Non memory)
*:
DOT PHASE, SIZE H, SHIFT H/V, SCAN CONV, ASPECT, and BLANKING in the “INPUT SETTING” menu have an initial value
respectively in accordance with the input signal (PRESET MEMORY No.).
** :
It differs in accordance with the resolution of the input signal.
Note : There are nonadjustable items in accordance with the input signal.
3-4
VPL-CS1
3-4. Service Kowhow
Cross Table of Board Replacement
Board Name
3-4-1. After Replacing the Prism Block
Device Name
Item Name
BA
C
P.DRV
VCOM (R)
*
\
VCOM (G)
*
\
VCOM (B)
*
\
CONT
*
95, 100 IRE
SUB CONT R
*
95,100 IRE
SUB CONT G
*
128 Fixed
SUB CONT B
*
95,100 IRE
BRT
*
2.8 V
1.
Perform Section “3-1-2-2. Polarizing Plate
Adjustment.”
2. Perform Section “3-2. V-COM Adjustment.”
3. Perform Section “3-5. White Balance Adjustment on
Servicing.”
3-4-2. After Replacing the Board
. Refer to the cross table below.
. There are no need to perform the adjustment when the board
other than the BA board or C board had been replaced.
W/B ADJUST
INPUT A-HIGH
3-4-2-1.When Replacing the BA Board
When the data before replacement can be read properly
1. Make a not of the data before replacement. After
replacement, write the data into the new board with
service mode.
2. If the white balance is extremely deteriorated, perform
the white balance adjustment (Refer to Section 3-5.).
When the data before replacement cannot be read
1. Perform Section “3-2. V-COM Adjustment.”
2. Perform Section “3-5. White Balance Adjustment on
Servicing.”
INPUT A-LOW
VIDEO-HIGH
3-4-2-2. When Replacing the C Board
1. Perform Section “3-2. V-COM Adjustment.”
2. Perform Section “3-5. White Balance Adjustment on
Servicing.”
3-4-2-3.When Replacing the Other Board
VIDEO-LOW
There are no need to perform the adjustment.
GAIN R
*
No
GAIN G
*
No
GAIN B
*
No
BIAS R
*
No
BIAS G
*
No
BIAS B
*
No
GAIN R
*
\
GAIN G
*
\
GAIN B
*
\
BIAS R
*
\
BIAS G
*
\
BIAS B
*
\
GAIN R
*
No
GAIN G
*
No
GAIN B
*
No
BIAS R
*
No
BIAS G
*
No
BIAS B
*
No
GAIN R
*
\
GAIN G
*
\
GAIN B
*
\
BIAS R
*
\
BIAS G
*
\
BIAS B
*
\
*:
When down the data befor replacement, and then
write in the data after the board replacement.
\:
Need adjustment
Value: See description.
VPL-CS1
3-5
3-5. White Balance Adjustment on
Servicing
3-5-1. Signal Level Adjustment
1. Input the 10 STEP signal to INPUT-A.
2. Warm up the unit at least 10 minutes. Enter the VAMP/BRT adjustment mode from the Service mode
as follows :
Service Mode → MENU → DEV. ADJ → P. DRV
→ VAMP/BRT.
3. Measure TP808, TP811, and TP812 on the C board
by osciloscope. Adujust V AMP/BRT so that the
minimum value in all black level is 2.8 V.
4. Input the 95 IRE and 100 IRE STEP signals.
5. Set the unit in G-only mode.
6. Enter the P.DRV on the MENU screen by the DEV.
ADJ.
7. Discriminate the 95 IRE and 100 IRE by the VAMP/CONT controls of the P.DRV.
8. Set the unit in R-only mode.
9. Discriminate the 95 IRE and 100 IRE by the VAMP/SUB CONT R controls of the P.DRV.
10. Set the unit in B-only mode.
11. Discriminate the 95 IRE and 100 IRE by the VAMP/SUB CONT B controls of the P.DRV.
3-5-2-2.LOW Mode of INPUT-A
1.
2.
3.
4.
5.
Input the 80 IRE FLAT FIELD signal to INPUT-A.
Set the GAIN G to 60 with the LOW mode of the W/B.
Measure the chromaticity (x, y).
Input the 25 IRE FLAT FIELD signal to INPUT-A.
Adjust the chromaticity (x, y) to the values measured in
step 3 by the BIAS G and B of the LOW mode of the W/B.
6. Repeat above steps 1 to 5 until the chromaticity become
the following values.
x ± 0.002, y ± 0.003 (The x and y are the values
measured in step 3.)
3-5-2-3.HIGH Mode of VIDEO
Switch the input to COMPONENT from INPUT-A by the
SET SETTING of the Menu screen.
Input the 15k COMPONENT 10 STEP signal to INPUT-A,
and observe the chromaticity of each luminance.
When varying the chromaticity of each luminance, perform
the following adjustments.
1.
2.
3.
4.
Input the 100 IRE FLAT FIELD signal to INPUT-A.
Measure the chromaticity (x, y).
Input the 50 IRE FLAT FIELD signal to INPUT-A.
Adjust the chromaticity (x, y) to the values measured in
step 2 by the V-AMP/SUB CONT R and B of the P. DRV.
3-5-2. White Balance Adjustment
3-5-2-4.LOW Mode of VIDEO
3-5-2-1.HIGH Mode of INPUT-A
Input the 10 STEP signal to INPUT-A, and observe the
chromaticity of each luminance.
When varying the chromaticity of each luminance,
perform the following adjustments.
1.
2.
3.
4.
3-6
Input the 100 IRE FLAT FIELD signal to INPUT-A.
Measure the chromaticity (x, y).
Input the 50 IRE FLAT FIELD signal to INPUT-A.
Adjust the chromaticity (x, y) to the values measured
in step 2 by the V-AMP/SUB CONT R and B of the
P. DRV.
1. Input the 80 IRE 15k COMPONENT FLAT FIELD
signal to INPUT-A.
2. Set the GAIN G to 60 with the LOW mode of the W/B.
3. Measure the chromaticity (x, y).
4. Input the 25 IRE FLAT FIELD signal to INPUT-A.
5. Adjust the chromaticity (x, y) to the values measured in
step 3 by the BIAS G and B of the LOW mode of the W/B.
6. Repeat above steps 1 to 5 until the chromaticity become
the following values.
x ± 0.002, y ± 0.003 (The x and y are the values
measured in step 3.)
VPL-CS1
3-6. Memory
When the power plug is connected to the power line
(Standby status), all data inside the internal ROM are
written into the NVM (Nonvolatile Memory). When the
power is turned to on, required data for the current picture,
such as status memory data, etc., are selected, and they are
written into the internal RAM. At this time, the gamma
memory data is not writing into the internal RAM but all
graphics/text data will be transferred to the register inside
the device instead.
Memory structure of VPL-CS1 series is based on the 600
series, and it is composed of the following seven memory
blocks.
1. Set memory
2. Status memory
3. Channel memory
4. Chroma memory
5. W/B memory
6. Reso memory
7. Gamma memory
When adjustment is carried out, adjustment data are
written into the NVM automatically (items on the user
mode) or by the trigger of memory operation (items on the
service mode and special service mode).
Adjustable items (W/B and Device Adjust) of the service
mode and special service are memorized into the NVM by
the memory operation. At the same time, the factory preset
(adjusted) data are all eliminated from the memory.
Set Memory
Set Memory
No.01
Status
Memory
Set Memory
No.01
Status
Memory
No.02
INPUT-A Preset
INPUT-A Preset
No.03
...
...
No.50
No.03
...
...
No.50
INPUT-A
User
Video
Input-A
Channel
Memory
HIGH
W/B
Memory
LOW
HIGH
LOW
Reso No. 0
...
...
No.90
Channel Memory
Chroma NT358/443/BW60
Memory PAL/PAL-M/N/
SECAM/BW50
15k Component
Reso
Memory
Reso No.17
Computer Others
Reso
Memory
Computer Others
W/B
Memory
No.71
...
Video
Input-A
Channel
Memory
Chroma NT358/443/BW60
Memory
PAL/PAL-M/N/
SECAM/BW50
15k Component
Status Memory
No.02
HIGH
Chroma Memory
W/B
Memory
LOW
HIGH
LOW
HIGH
LOW
Reso No. 0
...
...
Reso Memory
Reso No.17
CPU ROM
External NVM
Initialize
CPU RAM
Memory
Active memory copy
Gamma
Memory
VPL-CS1
Graphics
Text
Gamma
Memory
Graphics
Text
Output to device directly
3-7
Section 4
Semiconductors
BA033FP-E2
LT1376IS#TR
MC100ELT20DR2
NJM2073M(TE2)
SN74CBTD3306PWR
TC7W08FU
TL431BCDR2
FA5331M-TE1
TA78M09F(TE16L)
1
HN1B01FU-TE85R
DAN202K-T-146
2SA1162-YG-TE85L
2SA1213Y-TE12L
2SA1462
2SC2712-YG-TE85L
DTA144EKA-T146
DTC144EKA-T146
D1FL20U-TA
D1FS4A-TA
2 3
ISPLSI1016E-80LT44
TC7S04FU
TC7SH08FU-TE85R
BA12FP-E2
GND
TOP222Y-BB
TOP223Y-BB
IP00C711
192
128
2SC2873Y-TE12L
(TOP VIEW)
VCC
N.C
65
256
OUT
CXA1846BN
D10SC9M
129
193
1
64
M52749FP-TP
42
1
22
21
74VHC14MTCX
TC74LCX04FT(EL)
TC74LCX74FT
TC74VHCT04AFT
TC74VHCT04MTCX
TC74VHC125MTCX
FCQ20A06
2SD2114S-TP-V
Letter Side
PQ05SZ1U
D
G
S
CXA2112R-T6
2SK3013F-02
RS-140-T
RD8.2ES-T1B2
74VHC221AMTCX
CXA1875AM-T4
MAX4066CEE-TE2
CXA1839Q-T6
CXD2064Q-T6
RD24M-T1B2
RD8.2M-T1B1
74VHC240MTCX
MB88346BPFV-EF
VPL-CS1
4-1
SEC1801C
SEC2422C
SEC2422C
TF861S
1SS355TE-17
D2FS6-TA
DTZ-TT11-5.1
RB501V-40TE-17
RD5.6SB-T1
RD9.1SB2-T1
UDZ-TE-17-3.9B
4-2
VPL-CS1
Cover
Section 5
Exploded Views
NOTE :
• Items marked “ * ” are not stocked since they are seldom required
for routine service. Some delay should be anticipated when ordering these items.
The components identified marked ! are
critical for safety.
Replace only with the part number specified.
• Items with no part number and no description are not stocked because they are seldom required for routine service.
Les composants identifiés par la marque !
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
• The construction parts of an assembled part are indicated with a
collation number in the remarks column.
19
3
5-1. Cover
: 7-685-647-79
: 7-682-547-14
: 7-682-645-09
: 7-628-253-30
+BWTP 3x10
+BTP 3x10
+PS 3x5
+PS 2x8
12
17
21
13
20
21
14
20
22
10
16
23
18
15
24
11
25
6
4
26
8
9
7
5
1
8
3
27
2
REF NO.
PART NO.
DESCRIPTION
REMARK
REF NO.
PART NO.
DESCRIPTION
* 4-074-275-01
* X-4037-487-1
* 4-074-231-01
4-074-251-01
* 4-074-434-01
COVER, FRONT
HANDLE ASSY
EMBLEM (CS1)
SWITCH, LOCK
SPRING, EXTENSION
16
17
18
19
20
1-468-457-11
4-374-303-01
1-500-082-11
* 4-074-272-01
* 4-074-261-01
POWER, LAMP
RIVET, NYLON
CLAMP, SLEEVE FERRITE
COVER, TOP
HOUSE, STRAP
6
7
8
9
10
*
*
*
*
*
4-074-255-01
4-074-254-01
4-074-245-01
4-074-627-01
X-4037-461-1
HOLDER (L), FRONT COVER
HOLDER (R), FRONT COVER
HINGE (F)
COVER, BACK
PANEL ASSY, FRONT
21
22
23
24
25
*
*
*
*
HOLDER, S
KEY TOP
GUIDE (LED), LIGHT
H COMPL
SPEAKER (3.6CM)
11
12
13
14
15
*
*
*
*
3-704-176-51
A-1390-984-A
4-074-442-01
4-074-253-01
4-074-252-01
EMBLEM (NO.6), SONY
NF MOUNT
CATCHER (FC)
HOLDER (L), B
HOLDER (R), B
26
27
* 4-074-273-01
4-074-264-01
1
2
3
4
5
VPL-CS1
including 11
4-074-744-01
4-074-248-01
4-074-244-01
A-1375-195-A
1-529-544-11
REMARK
COVER, SIDE
SHAFT
5-1
Chassis
5-2. Chassis
: 7-682-646-09
: 7-682-253-30
: 7-685-647-79
: 7-685-903-21
: 7-685-645-79
: 7-682-247-09
+PS 3x5
+PS 2x8
+BVTP 3x10
+BTPWH 3x8
+BVTP 3x6
+K 3x6
66
58
67
69
68
64
52
56
51
61
62
71
72
53
63
54
57
70
60
59
65
73
55
74
75
76
REF NO.
PART NO.
DESCRIPTION
REMARK
REF NO.
PART NO.
DESCRIPTION
4-074-227-01
4-074-226-01
4-074-276-01
4-074-727-01
4-074-728-01
DUCT (T)
DUCT (B)
HOUSE, LAMP
LOUVER (A)
LOUVER (B)
51
52
53
54
55
* 4-074-983-01
* A-1335-123-A
4-066-309-01
A-1501-636-A
* X-4037-521-1
SPRING (CT), EARTH
C COMPL
SCREW, MACHINE, (+) P M4X8
OPTICS BLOCK ASSY
including 152 to 192
NOZZLE, ASSY
66
67
68
69
70
*
*
*
*
*
56
57
58
59
60
*
*
*
*
*
A-1136-048-A
A-1275-186-A
A-1136-049-A
4-074-914-01
4-074-664-01
BA COMPL
QA COMPL
B COMPL
COVER, SWITCH
LEVER, SWITCH
71
72
73
74
75
1-763-172-11
* 4-074-239-01
1-900-222-47
4-066-202-01
* X-4037-460-1
61
62
63
64
65
*
*
*
*
4-074-982-01
4-074-246-01
4-074-263-01
4-074-260-01
1-763-474-11
SPRING (VIDEO), EARTH
SLEEVE, VIDEO
FILTER, REAR
PLATE (QA)
FAN
76
4-066-202-01
5-2
FAN, DC
SCREW, FAN
CONNECTOR ASSY 2P
SCREW, M3
DOOR ASSY, LAMP
REMARK
including 76
SCREW, M3
VPL-CS1
Base
5-3. Base
: 7-685-547-14
: 7-682-247-09
: 7-682-646-09
: 7-682-245-04
+BTP 3x10
+K 3x6
+PS 3x5
+K 3x4
112
107
102
113
108
101
110
121
109
114
120
106
120
111
122
123
124
125
105
126
128
127
115
116
104
117
103
118
119
REF NO.
PART NO.
DESCRIPTION
REMARK
REF NO.
PART NO.
DESCRIPTION
101
102
103
104
105
* A-1316-492-A
1-500-082-11
* 4-074-660-01
! 1-251-382-12
4-066-309-01
GA COMPL
CLAMP, SLEEVE FERRITE
PLATE (AC)
INLET, AC 3P(WITH NOISE FILTE)
SCREW, MACHINE, (+) P M4X8
116
117
118
119
120
* 4-074-661-01
* 4-074-662-01
3-531-576-11
* 4-074-441-01
3-661-278-01
HOLDER, FAN
PLATE, FAN HOLDER
RIVET
COVER, FILTER
PIN, PARALLEL
106
107
108
109
110
*
*
*
*
*
4-074-663-01
4-074-256-01
4-074-258-01
4-074-435-01
4-074-247-01
SPRING (BL), EARTH
CASE (U), L
LOCK (REAR FOOT)
SPRING, COMPRESSION
ROD
121
122
123
124
125
* 4-074-241-01
* 4-074-242-01
3-703-358-03
* 4-074-984-01
* 4-074-729-01
HOLDER (L), REAR FOOT
HOLDER (R), REAR FOOT
PIN, PARALLEL (DIA. 2X8)
SPRING, TOSION
PLATE (RF)
111
112
113
114
115
*
*
*
*
*
4-074-257-01
4-074-724-01
4-075-060-01
4-074-725-01
4-074-274-01
CASE (B), L
CASE (RF)
SPRING, COMPRESSION
SLIDER (RF)
BASE
126
127
128
* 4-074-726-01
* 4-074-267-01
4-074-250-01
LEVER (RF)
FOOT, REAR
RUBBER, FOOT (R)
VPL-CS1
REMARK
5-3
Optics (1/2)
5-4. Optics (1/2)
: 7-682-547-04 +B 3x6
153
161
161
153
163
162
151
154
155
192
B
161
153
155
155
A
C
154
154
159
160
157
156
164
156
158
C
B
A
168
165
D
152
169
166
191
190
167
176
189
177
178
175
174
173
185
170
172
179
180
191
181
171
182
184
183
186
187
REF NO.
151
152
153
154
155
PART NO.
DESCRIPTION
A-1501-636-A
A-1484-705-A
4-074-425-01
4-074-474-01
4-066-174-01
OPTICS BLOCK ASSY
PRISM BLOCK ASSY
TAPE (A), SEAL
BSW M3X8
STOPPER (OPT), ROTATION
4-074-405-01
4-074-454-01
4-074-476-01
4-074-466-01
4-074-455-01
FASTENER (RB)
ADJUSTER, R-MIRROR
FASTNER (G)
ADJUSTER, G-MIRROR
ADJUSTER, B-MIRROR
188
REMARK
including 152 to 192
including 202 to 209
156
157
158
159
160
*
*
*
*
*
161
162
163
164
165
3-696-947-11
A-1501-633-A
A-1501-634-A
A-1501-635-A
* 4-074-429-01
SCREW(+B2.5)
PANEL (R) ASSY, IN-POLARIZER
PANEL (G) ASSY, IN-POLARIZER
PANEL (B) ASSY, IN-POLARIZER
STOPPER, RELAY LENS-2
166
167
168
169
170
*
*
*
*
*
STOPPER, RELAY LENS-1
STOPPER (GB), CH CONDENSER
STOPPER, FLY EYE
STOPPER, MAIN CONDENSER”
STOPPER, P/S
171
* 4-074-412-01
5-4
4-074-433-01
4-074-432-01
4-074-475-01
4-074-430-01
4-074-428-01
MIRROR, R-CHANNEL-2(OPT)
D
REF NO.
PART NO.
DESCRIPTION
REMARK
172
173
174
175
*
*
*
*
4-074-410-01
4-074-409-01
4-074-413-01
4-074-408-01
LENS (OPT), RELAY-3
LENS (OPT), RELAY-2
MIRROR, R-CHANNEL -1(OPT)
LENS (OPT), RELAY-1
176
177
178
179
180
*
*
*
*
*
4-074-407-01
4-074-427-01
4-074-406-01
4-074-411-01
4-074-414-01
DICHROICMIRROR, G-REFRECT(OPT)
CUSHION (B-DM)
DICHROICMIRROR, B-REFRECT(OPT)
FILTER (OPT), UV CUT
LENS, MAIN CONDENSER (OPT)
181
182
183
184
185
*
*
*
*
A-1484-706-A
4-074-426-01
4-074-449-01
4-074-416-01
4-074-418-01
P/S BLOCK ASSY
including 211 to 218
CUSHION (FLY EYE)
FLY EYE LENS-1
LENS, CONDENSER-R-CH(OPT)
LENS, CONDENSER-G-CH(OPT)
186
187
188
189
190
* 4-074-417-01
4-066-309-01
4-066-172-01
* 4-074-415-01
* 4-074-429-11
LENS, CONDENSER-B-CH(OPT)
SCREW, MACHINE, (+) P M4X8
FASTENER (OPT), MIRROR
MIRROR, B-CHANNEL (OPT)
STOPPER, RELAY LENS-2
191
192
* 4-074-426-11
* 4-075-039-01
CUSHION (FLY EYE)
SPACER (C) (OPT)
VPL-CS1
Optics (2/2)
5-5. Optics (2/2)
: 7-685-103-19 +P 2x5
: 7-682-948-01 +PSW 3x8
: 7-627-554-38 +P 2x1.8
211
212
213
214
201
215
216
202
203
202
217
218
204
205
206
202
210
209
207
208
REF NO.
PART NO.
DESCRIPTION
201
202
203
204
205
A-1484-705-A
4-074-473-01
A-1501-637-A
A-1501-638-A
A-1501-639-A
PRISM BLOCK ASSY
including 202 to 209
+K M1.7X6
PANEL (R) ASSY, OUT-POLARIZER
PANEL (G) ASSY, OUT-POLARIZER
PANEL (B) ASSY, OUT-POLARIZER
211
212
213
214
215
*
*
*
*
206
207
208
209
210
A-1484-705-A
A-1501-632-A
4-066-309-01
* 4-074-701-01
4-066-309-01
PRISM ASSY, 4P
LENS, PROJECTION
SCREW, MACHINE, (+) P M4X8
BRACKET, WINDOW
SCREW, MACHINE, (+) P M4X8
216
217
218
* 4-074-426-11
* 4-074-448-01
* 4-074-457-01
VPL-CS1
REMARK
REF NO.
PART NO.
DESCRIPTION
A-1484-706-A
4-074-456-01
4-074-446-01
4-074-477-01
4-074-471-01
P/S BLOCK ASSY
SPRING, P/S
CONVERTER, P/S (OPT)
SLIT, P/S
HOLDER, P/S
REMARK
including 211 to 218
CUSHION (FLY EYE)
FLY EYE LENS-2
SPRING, FLY EYE
5-5
BA
Section 6
Electrical Parts List
NOTE :
• Items marked * are not stocked since they are seldom required
for routine service. Some delay should be anticipated when ordering these items.
• Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components
used on the set.
The components identified marked ! are
critical for safety.
Replace only with the part number specified.
Les composants identifiés par la marque !
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
Ref.No.
Part No.
RESISTORS
• All resistors are in ohms.
• F: nonflammable
• METAL: Metal-film resistor
• METAL OXIDE: Metal oxide-film resistor
Description
Remark
* A-1136-048-A BA COMPL
**********************
<CAPACITOR>
Ref.No.
Part No.
Description
Remark
C291
C292
C293
C294
C295
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
0.01µF
0.01µF
0.01µF
0.01µF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C201
C202
C221
C222
C224
1-164-004-11
1-126-204-11
1-117-681-11
1-164-004-11
1-113-985-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
TANTAL. CHIP
0.1µF
47µF
100µF
0.1µF
10µF
10%
20%
20%
10%
20%
25V
16V
16V
25V
20V
C296
C297
C300
C301
C302
1-163-021-91
1-164-004-11
1-109-982-11
1-126-204-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01µF
0.1µF
1µF
47µF
0.1µF
10%
10%
10%
20%
10%
50V
25V
10V
16V
25V
C225
C226
C227
C228
C230
1-104-852-11
1-163-021-91
1-117-681-11
1-164-004-11
1-164-004-11
TANTAL. CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
22µF
0.01µF
100µF
0.1µF
0.1µF
20%
10%
20%
10%
10%
10V
50V
16V
25V
25V
C303
C304
C312
C313
C314
1-163-227-11
1-164-004-11
1-124-779-00
1-163-021-91
1-107-823-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
0.1µF
10µF
0.01µF
0.47µF
0.5PF
10%
20%
10%
10%
50V
25V
16V
50V
16V
C232
C233
C234
C235
C236
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-117-681-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1µF
0.1µF
0.1µF
0.1µF
100µF
10%
10%
10%
10%
20%
25V
25V
25V
25V
16V
C315
C317
C318
C319
C320
1-163-021-91
1-163-021-91
1-126-603-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
0.01µF
4.7µF
0.1µF
0.1µF
10%
10%
20%
10%
10%
50V
50V
35V
25V
25V
C237
C238
C239
C240
C241
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C321
C322
C323
C324
C325
1-164-004-11
1-164-004-11
1-125-838-91
1-163-037-11
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
2.2µF
0.022µF
0.01µF
10%
10%
10%
10%
10%
25V
25V
6.3V
50V
50V
C242
C243
C244
C245
C246
1-164-004-11
1-163-037-11
1-163-009-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.022µF
0.001µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
25V
50V
50V
25V
25V
C326
C327
C328
C330
C331
1-109-982-11
1-164-004-11
1-109-982-11
1-163-021-91
1-126-204-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
1µF
0.1µF
1µF
0.01µF
47µF
10%
10%
10%
10%
20%
10V
25V
10V
50V
16V
C247
C274
C275
C276
C277
1-131-998-21
1-104-823-11
1-164-004-11
1-163-021-91
1-163-021-91
TANTALUM
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
82µF
47µF
0.1µF
0.01µF
0.01µF
20%
20%
10%
10%
10%
6.3V
16V
25V
50V
50V
C332
C333
C334
C337
C338
1-163-021-91
1-126-204-11
1-163-021-91
1-163-021-91
1-164-004-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
47µF
0.01µF
0.01µF
0.1µF
10%
20%
10%
10%
10%
50V
16V
50V
50V
25V
C278
C279
C280
C281
C282
1-163-021-91
1-107-682-11
1-124-779-00
1-109-982-11
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
1µF
10µF
1µF
0.01µF
10%
10%
20%
10%
10%
50V
16V
16V
10V
50V
C283
C284
C285
C286
C287
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
0.01µF
0.01µF
0.01µF
0.01µF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
VPL-CS1
<CONNECTOR>
CN201
* 1-785-305-21 CONNECTOR, BOARD TO BOARD 70P
<FERRITEBEAD>
FB201
FB202
FB271
1-414-235-22 INDUCTOR CHIP
1-500-245-11 INDUCTOR CHIP
1-414-235-22 INDUCTOR CHIP
0µH
0µH
0µH
6-1
BA
Ref.No.
Part No.
Description
Remark
<FILTER>
FL221
FL222
FL223
FL301
FL302
1-239-397-11
1-239-397-11
1-239-397-11
1-239-899-21
1-239-899-21
FILTER, LOW PASS
FILTER, LOW PASS
FILTER, LOW PASS
FILTER, CHIP EMI
FILTER, CHIP EMI
FL303
1-239-899-21 FILTER, CHIP EMI
<IC>
IC201
IC202
IC221
IC271
IC301
8-752-072-94
8-759-492-55
8-752-390-37
8-752-070-54
8-752-094-47
IC CXA1875AM-T4
IC M24C64-WMN6T
IC CXD2064Q-T6
IC CXA1839Q-T6
IC CXA2123AQ-T6
IC302
8-759-494-88 IC TC75S56F(TE85R)
<COIL>
L221
L222
L223
L224
L225
1-414-753-91
1-414-235-22
1-414-753-91
1-414-753-91
1-414-753-91
INDUCTOR
INDUCTOR CHIP
INDUCTOR
INDUCTOR
INDUCTOR
4.7µH
0µH
4.7µH
4.7µH
4.7µH
L226
L271
1-414-753-91 INDUCTOR
1-414-235-22 INDUCTOR CHIP
4.7µH
0µH
<TRANSISTOR>
Q221
Q222
Q226
Q227
Q228
8-729-230-49
8-729-216-22
8-729-216-22
8-729-230-49
8-729-216-22
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SA1162-G
Q229
Q271
Q272
Q273
Q302
8-729-230-49
8-729-013-28
8-729-013-28
8-729-013-28
8-729-230-49
TRANSISTOR 2SC2712-YG
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR 2SC2712-YG
Q303
8-729-230-49 TRANSISTOR 2SC2712-YG
Ref.No.
Part No.
Description
Remark
R228
R230
R231
1-216-049-91 RES,CHIP
1-216-085-00 RES,CHIP
1-216-051-00 RES,CHIP
1K
33K
1.2K
5%
5%
5%
1/10W
1/10W
1/10W
R234
R235
R236
R237
R239
1-216-067-00
1-216-043-91
1-216-295-91
1-216-049-91
1-216-049-91
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
5.6K
560
1/10W
1/10W
1K
1K
5%
5%
0
5%
5%
R242
R243
R244
R245
R247
1-216-067-00
1-216-043-91
1-216-025-91
1-216-049-91
1-216-043-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
5.6K
560
100
1K
560
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R249
R250
R251
R252
R253
1-216-631-11
1-216-631-11
1-216-053-00
1-216-061-00
1-216-057-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
150
150
1.5K
3.3K
2.2K
0.50%
0.50%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R254
R255
R256
R258
R259
1-216-091-00
1-216-043-91
1-216-295-91
1-216-295-91
1-216-295-91
RES,CHIP
RES,CHIP
SHORT
SHORT
SHORT
56K
560
0
0
0
5%
5%
1/10W
1/10W
R271
R272
R273
R274
R275
1-216-025-91
1-216-635-11
1-216-655-11
1-216-083-00
1-216-295-91
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
SHORT
100
220
1.5K
27K
0
5%
0.50%
0.50%
5%
1/10W
1/10W
1/10W
1/10W
R276
R277
R278
R279
R280
1-216-081-00
1-216-085-00
1-216-647-11
1-216-655-11
1-216-081-00
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
22K
33K
680
1.5K
22K
5%
5%
0.50%
0.50%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R281
R282
R283
R284
R285
1-216-295-91
1-216-085-00
1-216-073-00
1-216-025-91
1-216-025-91
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
0
33K
10K
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R286
R287
R288
R289
R290
1-216-651-11
1-216-651-11
1-216-025-91
1-216-025-91
1-216-025-91
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
1K
100
100
100
0.50%
0.50%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R291
R292
R293
R294
R296
1-216-081-00
1-216-085-00
1-216-295-91
1-216-049-91
1-216-033-00
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
22K
33K
0
1K
220
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R298
R299
R300
R302
R303
1-216-025-91
1-216-025-91
1-216-025-91
1-216-295-91
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
SHORT
100
100
100
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R304
R305
R306
R309
R310
1-208-796-11
1-216-025-91
1-216-037-00
1-216-663-11
1-216-685-11
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
3.9K
100
330
3.3K
27K
0.50% 1/10W
5%
1/10W
5%
1/10W
0.50% 1/10W
0.50% 1/10W
R311
R312
R313
R314
R315
1-216-667-11
1-216-025-91
1-216-025-91
1-216-049-91
1-216-049-91
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
4.7K
100
100
1K
1K
0.50%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R316
R317
R318
1-216-061-00 RES,CHIP
1-216-069-00 RES,CHIP
1-216-017-91 RES,CHIP
3.3K
6.8K
47
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<RESISTOR>
R201
R202
R203
R204
R205
1-216-065-91
1-216-073-00
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
4.7K
10K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R206
R207
R208
R209
R210
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R211
R212
R213
R214
R215
1-216-073-00
1-216-073-00
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R216
R217
R218
R222
R223
1-216-073-00
1-216-073-00
1-216-073-00
1-216-081-00
1-216-065-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
10K
22K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R225
R227
1-216-043-91 RES,CHIP
1-216-049-91 RES,CHIP
560
1K
5%
5%
1/10W
1/10W
6-2
VPL-CS1
BA B
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
Remark
R319
R320
1-216-017-91 RES,CHIP
1-216-017-91 RES,CHIP
47
47
5%
5%
1/10W
1/10W
C454
C455
1-107-826-91 CERAMIC CHIP 0.1µF
1-107-826-91 CERAMIC CHIP 0.1µF
10%
10%
16V
16V
R321
R322
R324
1-216-025-91 RES,CHIP
1-216-295-91 SHORT
1-216-017-91 RES,CHIP
100
0
47
5%
1/10W
5%
1/10W
C456
C457
C458
C459
C460
1-110-563-11
1-162-970-11
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.068µF
0.01µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
25V
16V
16V
16V
C461
C462
C463
C464
C465
1-110-563-11
1-107-826-91
1-162-970-11
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.068µF
0.1µF
0.01µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
25V
16V
16V
C466
C467
C468
C469
C470
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C471
C472
C473
C474
C475
1-162-970-11
1-107-826-91
1-107-826-91
1-107-826-91
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
0.1µF
0.1µF
0.1µF
0.22µF
10%
10%
10%
10%
10%
25V
16V
16V
16V
10V
C477
C478
C479
C480
C481
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C482
C483
C484
C485
C486
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C487
C489
C490
C491
C495
1-126-205-11
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
0.1µF
0.1µF
0.1µF
0.1µF
20%
10%
10%
10%
10%
6.3V
16V
16V
16V
16V
C496
C497
C498
C499
C500
1-107-826-91
1-107-826-91
1-107-826-91
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
100PF
100PF
10%
10%
10%
5%
5%
16V
16V
16V
50V
50V
C501
C502
C503
C504
C505
1-107-826-91
1-162-927-11
1-107-826-91
1-126-205-11
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1µF
100PF
0.1µF
47µF
0.1µF
10%
5%
10%
20%
10%
16V
50V
16V
6.3V
16V
C506
C507
C508
C509
C510
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C511
C512
C513
C514
C515
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C516
C517
C518
C519
C520
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C521
C522
C523
C524
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
16V
16V
16V
16V
<CRYSTAL>
X301
1-781-730-21 VIBRATOR, CRYSTAL (16.2MHz)
*************************************************************
* A-1136-049-A B COMPL
**********************
<CAPACITOR>
C401
C402
C403
C404
C405
1-107-826-91
1-162-927-11
1-107-826-91
1-162-970-11
1-126-204-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1µF
100PF
0.1µF
0.01µF
47µF
10%
5%
10%
10%
20%
16V
50V
16V
25V
16V
C406
C407
C408
C409
C410
1-126-205-11
1-126-205-11
1-107-826-91
1-107-826-91
1-107-826-91
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
47µF
0.1µF
0.1µF
0.1µF
20%
20%
10%
10%
10%
6.3V
6.3V
16V
16V
16V
C411
C412
C413
C414
C415
1-162-927-11
1-107-826-91
1-107-826-91
1-162-970-11
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1µF
0.1µF
0.01µF
0.1µF
5%
10%
10%
10%
10%
50V
16V
16V
25V
16V
C416
C417
C420
C421
C422
1-162-967-11
1-126-204-11
1-107-826-91
1-107-826-91
1-162-970-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0033µF
47µF
0.1µF
0.1µF
0.01µF
10%
20%
10%
10%
10%
50V
16V
16V
16V
25V
C424
C426
C427
C428
C429
1-126-204-11
1-107-826-91
1-115-566-11
1-164-816-11
1-115-566-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
0.1µF
4.7µF
220PF
4.7µF
20%
10%
10%
2%
10%
16V
16V
10V
50V
10V
C430
C431
C432
C433
C434
1-107-826-91
1-162-970-11
1-124-778-00
1-115-566-11
1-115-566-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.01µF
22µF
4.7µF
4.7µF
10%
10%
20%
10%
10%
16V
25V
6.3V
10V
10V
C435
C436
C437
C438
C439
1-115-566-11
1-110-563-11
1-124-779-00
1-162-927-11
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7µF
0.068µF
10µF
100PF
0.1µF
10%
10%
20%
5%
10%
10V
16V
16V
50V
16V
C440
C442
C443
C444
C445
1-162-927-11
1-107-826-91
1-126-205-11
1-124-778-00
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
100PF
0.1µF
47µF
22µF
0.1µF
5%
10%
20%
20%
10%
50V
16V
6.3V
6.3V
16V
C446
C447
C448
C449
C450
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C451
C452
C453
1-107-826-91 CERAMIC CHIP 0.1µF
10%
1-110-563-11 CERAMIC CHIP 0.068µF 10%
1-162-970-11 CERAMIC CHIP 0.01µF 10%
16V
16V
25V
VPL-CS1
6-3
B
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
<DIODE>
C525
1-107-826-91 CERAMIC CHIP 0.1µF
10%
16V
C526
C527
C528
C529
C530
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
D401
D402
D403
D404
D406
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
DIODE 1SS226
C531
C532
C533
C534
C535
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
D408
D409
D410
D411
D412
8-719-914-43
8-719-914-43
8-719-158-15
8-719-158-15
8-719-158-15
DIODE DAN202K
DIODE DAN202K
DIODE RD5.6SB
DIODE RD5.6SB
DIODE RD5.6SB
C536
C537
C538
C539
C540
1-107-826-91
1-162-970-11
1-115-156-11
1-107-826-91
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.01µF
1µF
0.1µF
1µF
10%
10%
16V
25V
10V
16V
10V
D413
D414
D415
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
8-719-158-15 DIODE RD5.6SB
C541
C542
C543
C544
C545
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-164-315-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
470PF
10%
10%
10%
10%
5%
16V
16V
16V
16V
50V
C546
C547
C548
C549
C550
1-162-915-11
1-162-915-11
1-124-778-00
1-107-826-91
1-124-778-00
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
10PF
10PF
22µF
0.1µF
22µF
0.5PF
0.5PF
20%
10%
20%
50V
50V
6.3V
16V
6.3V
C551
C553
C554
C555
C556
1-107-826-91
1-107-826-91
1-162-927-11
1-124-778-00
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1µF
0.1µF
100PF
22µF
0.01µF
10%
10%
5%
20%
10%
16V
16V
50V
6.3V
25V
C557
C558
C559
C560
C561
1-107-826-91
1-124-778-00
1-107-826-91
1-162-966-11
1-107-826-91
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
22µF
0.1µF
0.0022µF
0.1µF
10%
20%
10%
10%
10%
16V
6.3V
16V
50V
16V
C562
C563
C564
C565
C566
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C567
C568
C569
C571
C572
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
1-107-826-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C573
C574
C575
C576
C577
1-107-826-91
1-124-778-00
1-162-970-11
1-107-826-91
1-124-778-00
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1µF
22µF
0.01µF
0.1µF
22µF
10%
20%
10%
10%
20%
16V
6.3V
25V
16V
6.3V
C578
C579
C581
1-107-826-91 CERAMIC CHIP 0.1µF
1-162-970-11 CERAMIC CHIP 0.01µF
1-107-826-91 CERAMIC CHIP 0.1µF
10%
10%
10%
16V
25V
16V
10%
Remark
<FERRITE BEAD>
<CONNECTOR>
CN401
CN402
CN403
CN404
CN405
* 1-785-305-21
* 1-793-797-21
* 1-793-797-21
1-569-577-41
1-774-932-21
CN406
* 1-691-551-11 PIN, CONNECTOR (SMD) 8P
6-4
CONNECTOR, BOARD TO BOARD 70P
CONNECTOR, BOARD TO BOARD
CONNECTOR, BOARD TO BOARD
CONNECTOR, D-SUB 15P
CONNECTOR, FF C/FPC (ZIF) 32P
FB401
FB402
FB403
FB404
FB405
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0µH
0µH
0µH
0µH
0µH
FB406
FB407
FB409
FB410
FB411
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0µH
0µH
0µH
0µH
0µH
FB412
FB413
FB414
1-414-234-22 INDUCTOR CHIP
1-414-234-22 INDUCTOR CHIP
1-414-234-22 INDUCTOR CHIP
0µH
0µH
0µH
<IC>
IC401
IC402
IC403
IC404
IC405
8-759-472-00
8-759-472-37
8-759-196-96
8-759-541-25
8-759-472-35
IC 74VHC14MTCX
IC 74VHC240MTCX
IC TC7SH08FU-TE85R
IC M52758FP
IC 74VHC221AMTCX
IC406
IC407
IC408
IC409
IC410
8-752-072-94
8-759-646-02
8-759-475-39
8-759-645-12
8-759-473-74
IC CXA1875AM-T4
IC M52347FP-TE
IC TC74LCX74FT(EL)
IC AD9884AKS-140
IC SN74CBTD3306PWR
IC411
IC412
IC413
IC417
IC418
8-759-472-14
8-759-563-33
8-759-660-44
8-759-647-95
8-759-082-58
IC 74VHC125MTCX
IC CXD8774R
IC THC63LVDM83A-T
IC IP00C711
IC TC7W08FU
IC419
IC420
IC421
IC423
IC424
8-759-582-91
8-759-544-01
8-759-475-35
8-759-389-68
8-759-655-76
IC S-80842ANNP-ED6-T2
IC S-80828ANNP-EDR-T2
IC TC74LCX04FT(EL)
IC 74VHCT04MTCX
IC MB90098APF-G-104-BND-ER
IC425
IC426
IC427
IC428
IC429
8-759-475-53
8-759-557-86
8-759-648-10
8-759-058-58
8-759-442-20
IC TC74LCX541FT(EL)
IC NC7SZ86P5X
IC HD64F2633TE
IC TC7S04FU(TE85R)
IC 24LC21AT/SN
IC430
8-759-277-63 IC TC7W14FU(TE12R)
<COIL>
L401
L402
L403
L404
1-412-057-21
1-500-451-11
1-414-752-11
1-414-752-11
INDUCTOR CHIP
FERRITE
INDUCTOR
INDUCTOR
6.8µH
0µH
2.2µH
2.2µH
VPL-CS1
B
Ref.No.
Part No.
Description
Remark
<TRANSISTOR>
Q401
Q402
Q403
Q404
Q405
8-729-013-28
8-729-013-28
8-729-101-07
8-729-230-49
8-729-140-63
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR 2SB798-DL
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SA1611-M5M6
Ref.No.
Part No.
Description
Remark
R461
R462
R463
1-216-833-91 RES,CHIP
1-216-833-91 RES,CHIP
1-216-833-91 RES,CHIP
10K
10K
10K
5%
5%
5%
1/16W
1/16W
1/16W
R464
R465
R466
R467
R468
1-216-833-91
1-216-833-91
1-216-833-91
1-216-833-91
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R469
R470
R471
R472
R473
1-216-833-91
1-216-827-11
1-216-827-11
1-216-809-11
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
3.3K
3.3K
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R474
R476
R477
R479
R480
1-218-694-11
1-216-801-11
1-216-801-11
1-216-833-91
1-216-839-11
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.2K
22
22
10K
33K
0.50%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R481
R482
R483
R484
R485
1-216-839-11
1-216-805-11
1-216-821-11
1-216-811-11
1-216-841-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
33K
47
1K
150
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R486
R487
R488
R489
R490
1-216-808-11
1-216-805-11
1-218-675-11
1-216-833-91
1-218-703-11
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
82
47
200
10K
3K
5%
5%
0.50%
5%
0.50%
1/16W
1/16W
1/16W
1/16W
1/16W
R491
R492
R495
R496
R497
1-216-809-11
1-216-864-11
1-216-821-11
1-216-805-11
1-216-805-11
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
100
0
1K
47
47
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
R499
R500
R501
R502
R503
1-216-805-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-825-11
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
47
0
100
100
2.2K
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
R504
R505
R506
R507
R508
1-216-809-11
1-216-825-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
2.2K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R509
R510
R511
R512
R513
1-216-833-91
1-216-833-91
1-216-801-11
1-216-833-91
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
22
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R514
R515
R516
R517
R518
1-216-833-91
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R519
R520
R521
R522
R523
1-216-833-91
1-216-809-11
1-216-833-91
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
100
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R524
R525
R526
R527
R528
1-216-825-11
1-216-825-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
2.2K
2.2K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R529
R530
R531
1-216-833-91 RES,CHIP
1-216-833-91 RES,CHIP
1-216-809-11 RES,CHIP
10K
10K
100
5%
5%
5%
1/16W
1/16W
1/16W
<RESISTOR>
R401
R402
R403
R404
R405
1-216-805-11
1-216-809-11
1-216-821-11
1-216-805-11
1-216-805-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47
100
1K
47
47
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R406
R407
R408
R409
R410
1-216-805-11
1-216-809-11
1-216-833-91
1-216-625-11
1-216-805-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
47
100
10K
82
47
5%
5%
5%
0.50%
5%
1/16W
1/16W
1/16W
1/10W
1/16W
R411
R412
R413
R414
R415
1-218-668-11
1-218-716-11
1-216-686-11
1-216-805-11
1-218-696-11
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
100
10K
560
47
1.5K
5%
1/16W
0.50% 1/16W
5%
1/16W
5%
1/16W
0.50% 1/16W
R416
R417
R418
R419
R420
1-216-797-11
1-218-668-11
1-218-686-11
1-216-625-11
1-218-668-11
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
100
560
82
100
5%
1/16W
5%
1/16W
5%
1/16W
0.50% 1/10W
5%
1/16W
R421
R422
R423
R424
R425
1-218-686-11
1-216-833-91
1-216-809-11
1-216-809-11
1-216-805-11
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
560
10K
100
100
47
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R426
R427
R428
R429
R430
1-216-625-11
1-216-833-91
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
82
10K
100
100
100
0.50%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R431
R432
R433
R434
R435
1-216-833-91
1-216-805-11
1-216-864-11
1-218-708-11
1-216-821-11
RES,CHIP
RES,CHIP
SHORT
METAL CHIP
RES,CHIP
10K
47
0
4.7K
1K
5%
5%
1/16W
1/16W
R436
R437
R438
R439
R440
1-216-821-11
1-216-841-11
1-216-864-11
1-216-805-11
1-216-821-11
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
1K
47K
0
47
1K
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R443
R444
R445
R446
R447
1-216-827-11
1-216-805-11
1-216-864-11
1-218-732-11
1-216-821-11
RES,CHIP
RES,CHIP
SHORT
METAL CHIP
RES,CHIP
3.3K
47
0
47K
1K
5%
5%
1/16W
1/16W
R448
R449
R450
R451
R452
1-216-811-11
1-216-864-11
1-216-864-11
1-216-821-11
1-216-821-11
RES,CHIP
SHORT
SHORT
RES,CHIP
RES,CHIP
150
0
0
1K
1K
5%
1/16W
5%
5%
1/16W
1/16W
R453
R454
R455
R456
R458
1-216-810-11
1-216-805-11
1-216-805-11
1-216-801-11
1-216-801-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
120
47
47
22
22
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R459
R460
1-216-833-91 RES,CHIP
1-216-833-91 RES,CHIP
10K
10K
5%
5%
1/16W
1/16W
VPL-CS1
0.50% 1/16W
5%
1/16W
0.50% 1/16W
5%
1/16W
6-5
B QA
Ref.No.
Part No.
Description
Remark
R532
R533
1-216-809-11 RES,CHIP
1-216-809-11 RES,CHIP
100
100
5%
5%
1/16W
1/16W
R534
R535
R536
R537
R538
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-91
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R539
R540
R541
R542
R543
1-216-833-91
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R544
R545
R546
R547
R548
1-216-801-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
22
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R549
R550
R551
R553
R554
1-216-809-11
1-216-833-91
1-216-833-91
1-216-809-11
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
10K
10K
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R555
R556
R557
R558
R559
1-216-825-11
1-216-825-11
1-216-821-11
1-216-809-11
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
2.2K
2.2K
1K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R560
R561
R562
R563
R564
1-216-833-91
1-216-833-91
1-216-809-11
1-216-833-91
1-216-833-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
100
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R565
R566
R567
R568
R576
1-216-833-91
1-216-829-11
1-216-829-11
1-216-833-91
1-216-809-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
4.7K
4.7K
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R577
R583
R584
R585
R587
1-216-809-11
1-216-809-11
1-216-833-91
1-216-797-11
1-216-835-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
10K
10
15K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R588
R589
R590
R591
R592
1-216-835-11
1-216-841-11
1-216-845-11
1-216-805-11
1-216-805-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15K
47K
100K
47
47
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R593
R594
R595
R597
1-216-813-11
1-216-817-11
1-216-817-11
1-216-821-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
220
470
470
1K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
Ref.No.
Part No.
Description
Remark
RB413
RB414
RB415
1-233-576-11 RES, CHIP NET WORK 10 0
1-233-576-11 RES, CHIP NET WORK 10 0
1-233-576-11 RES, CHIP NET WORK 10 0
RB416
RB417
RB418
RB419
RB520
1-233-576-11
1-233-576-11
1-233-576-11
1-239-409-11
1-233-576-11
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
WORK 10 0
WORK 10 0
WORK 10 0
WORK 47-3216
WORK 10 0
RB521
RB522
RB523
RB524
RB525
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
RB526
1-233-576-11 RES, CHIP NET WORK 10 0
<THERMISTOR>
TH201
1-809-020-11 THERMISTOR
<TEST PIN>
TP401
TP402
TP403
TP404
TP405
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
TP406
TP407
1-535-757-11 CHIP, CHECKER
1-535-757-11 CHIP, CHECKER
<CRYSTAL>
X401
X402
X403
1-781-420-21 OSCILLATOR, CRYSTAL (52MHz)
1-781-063-21 OSCILLATOR, CRYSTAL (70MHz)
1-781-659-21 VIBRATOR, CRYSTAL (12.288MHz)
*************************************************************
* A-1275-186-B QA COMPL
**********************
<CAPACITOR>
C101
C102
C103
C104
C105
1-124-779-00
1-126-204-11
1-126-204-11
1-113-985-11
1-113-985-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
TANTAL. CHIP
TANTAL. CHIP
10µF
47µF
47µF
10µF
10µF
20%
20%
20%
20%
20%
16V
16V
16V
20V
20V
C106
C107
C108
C109
C110
1-126-395-11
1-126-395-11
1-126-205-11
1-126-205-11
1-126-397-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
22µF
22µF
47µF
47µF
33µF
20%
20%
20%
20%
20%
16V
16V
6.3V
6.3V
25V
C111
C112
C113
C114
C115
1-126-204-11
1-126-395-11
1-131-998-21
1-164-182-11
1-164-004-11
ELECT CHIP
ELECT CHIP
TANTALUM
CERAMIC CHIP
CERAMIC CHIP
47µF
22µF
82µF
0.0033µF
0.1µF
20%
20%
20%
10%
10%
16V
16V
6.3V
50V
25V
C116
C117
C118
C119
C120
1-126-395-11
1-126-205-11
1-119-667-11
1-113-500-11
1-109-982-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
22µF
47µF
22µF
100µF
1µF
20%
20%
16V
6.3V
10V
10V
10V
C121
C122
C123
1-164-004-11 CERAMIC CHIP 0.1µF
1-117-681-11 ELECT CHIP
100µF
1-119-667-11 CERAMIC CHIP 22µF
10%
20%
<NETWORK>
RB401
RB402
RB403
RB404
RB405
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
RB406
RB407
RB408
RB409
RB410
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
1-233-576-11
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
RES, CHIP NET
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
WORK 10 0
RB411
RB412
1-233-576-11 RES, CHIP NET WORK 10 0
1-233-576-11 RES, CHIP NET WORK 10 0
6-6
20%
10%
25V
16V
10V
VPL-CS1
QA
Ref.No.
Part No.
Description
Remark
C124
C125
1-109-982-11 CERAMIC CHIP 1µF
1-163-251-11 CERAMIC CHIP 100PF
10%
5%
10V
50V
C126
C127
C128
C129
C130
1-163-251-11
1-164-004-11
1-126-205-11
1-126-205-11
1-126-205-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
100PF
0.1µF
47µF
47µF
47µF
5%
10%
20%
20%
20%
50V
25V
6.3V
6.3V
6.3V
C131
C132
C133
C134
C135
1-126-205-11
1-126-205-11
1-163-251-11
1-126-205-11
1-109-982-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47µF
47µF
100PF
47µF
1µF
20%
20%
5%
20%
10%
6.3V
6.3V
50V
6.3V
10V
C136
C137
C138
C139
C140
1-117-370-11
1-163-251-11
1-109-982-11
1-164-004-11
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10µF
100PF
1µF
0.1µF
0.01µF
5%
10%
10%
10%
10V
50V
10V
25V
50V
C141
C142
C143
C144
C146
1-164-004-11
1-126-206-11
1-163-021-91
1-164-004-11
1-164-004-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
100µF
0.01µF
0.1µF
0.1µF
10%
20%
10%
10%
10%
25V
6.3V
50V
25V
25V
C148
C149
C150
C151
C152
1-164-004-11
1-163-227-11
1-163-227-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
10PF
10PF
0.1µF
0.1µF
10%
0.5PF
0.5PF
10%
10%
25V
50V
50V
25V
25V
C153
C154
C155
C156
C157
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C158
C159
C160
C161
C162
1-163-021-91
1-163-239-11
1-163-239-11
1-164-004-11
1-124-778-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.01µF
33PF
33PF
0.1µF
22µF
10%
5%
5%
10%
20%
50V
50V
50V
25V
6.3V
C163
C164
C165
C166
C169
1-124-778-00
1-163-239-11
1-163-239-11
1-164-004-11
1-164-004-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22µF
33PF
33PF
0.1µF
0.1µF
20%
5%
5%
10%
10%
6.3V
50V
50V
25V
25V
Ref.No.
Part No.
Description
Remark
D122
D123
D124
D125
D126
8-719-158-15
8-719-058-24
8-719-422-12
8-719-422-12
8-719-158-15
DIODE RD5.6SB
DIODE RB501V-40TE-17
DIODE MA8039
DIODE MA8039
DIODE RD5.6SB
D127
D128
D129
D130
D131
8-719-158-15
8-719-158-15
8-719-422-12
8-719-422-12
8-719-914-43
DIODE RD5.6SB
DIODE RD5.6SB
DIODE MA8039
DIODE MA8039
DIODE DAN202K
D133
D135
8-719-058-24 DIODE RB501V-40TE-17
8-719-058-24 DIODE RB501V-40TE-17
<FERRITE BEAD>
FB121
FB122
FB123
FB124
FB125
1-414-234-22
1-469-185-11
1-414-234-22
1-414-234-22
1-469-185-11
INDUCTOR CHIP
FERRITE
INDUCTOR CHIP
INDUCTOR CHIP
FERRITE
0µH
0µH
0µH
0µH
0µH
FB126
FB127
FB128
FB129
FB130
1-216-295-91
1-469-185-11
1-414-234-22
1-414-234-22
1-414-234-22
SHORT
FERRITE
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0
0µH
0µH
0µH
0µH
FB131
FB132
FB133
FB134
FB136
1-469-185-11
1-414-234-22
1-216-295-91
1-216-295-91
1-500-451-11
FERRITE
INDUCTOR CHIP
SHORT
SHORT
FERRITE
0µH
0µH
0
0
0µH
FB137
FB138
FB139
1-216-295-91 SHORT
1-216-295-91 SHORT
1-500-451-11 FERRITE
0
0
0µH
<FILTER>
FL101
FL102
FL103
FL104
FL105
1-239-899-21
1-239-899-21
1-239-899-21
1-239-899-21
1-239-899-21
FILTER, CHIP
FILTER, CHIP
FILTER, CHIP
FILTER, CHIP
FILTER, CHIP
EMI
EMI
EMI
EMI
EMI
<IC>
<CONNECTOR>
CN101
CN102
CN103
CN104
CN105
* 1-580-057-11
* 1-760-388-11
* 1-785-306-21
* 1-785-306-21
* 1-793-798-21
PIN, CONNECTOR (SMD) 4P
CONNECTOR PIN(SMD) 9 PIN
CONNECTOR, BOARD TO BOARD 70P
CONNECTOR, BOARD TO BOARD 70P
CONNECTOR, BOARD TO BOARD
CN106
CN122
CN123
1-784-292-11 CONNECTOR, MINIATUREDIN 4P
1-794-081-21 CONNECTOR, ROUND TYPE 6P
* 1-580-056-21 PIN, CONNECTOR (SMD) 3P
<DIODE>
D101
D102
D103
D104
D105
8-719-158-15
8-719-158-15
8-719-158-15
8-719-158-15
8-719-158-37
DIODE RD5.6SB
DIODE RD5.6SB
DIODE RD5.6SB
DIODE RD5.6SB
DIODE RD9.1SB2
D106
D107
D108
D109
D121
8-719-158-37
8-719-055-30
8-719-055-30
8-719-988-61
8-719-058-24
DIODE RD9.1SB2
DIODE D1FS4A-TA
DIODE D1FS4A-TA
DIODE 1SS355TE-17
DIODE RB501V-40TE-17
VPL-CS1
IC101
IC102
IC103
IC104
IC105
8-759-460-72
8-759-460-72
8-759-335-28
8-759-157-17
8-759-637-94
IC BA033FP-E2
IC BA033FP-E2
IC TA78M09F(TE16L)
IC PQ05SZ1U
IC LT1376IS#TR
IC106
IC107
IC108
IC121
IC122
8-759-157-17
8-759-066-55
8-759-066-55
8-719-066-43
8-759-654-25
IC PQ05SZ1U
IC TA75W393FU
IC TA75W393FU
DIODE GP1U28Y
IC RCV4-A1S-OTP
IC123
IC124
IC125
IC127
IC128
8-759-653-02
8-759-582-91
8-759-666-01
8-759-655-55
8-759-655-59
IC IRMF
IC S-80842ANNP-ED6-T2
IC ST72T631L4M1-101
IC UPD72012GB-003-3B4
IC UPD16875G-E2
<JACK>
J101
J102
J121
J122
1-794-014-11
1-566-822-21
1-793-994-21
1-779-677-11
PIN, JACK
JACK
CONNECTOR, USB
CONNECTOR, USB (B)
6-7
QA
Ref.No.
Part No.
Description
Remark
<COIL>
L101
L102
L103
L104
L105
1-500-451-11
1-412-363-21
1-412-363-21
1-412-363-21
1-412-363-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0µH
0µH
0µH
0µH
0µH
L106
L107
L108
L109
L131
1-412-363-21
1-412-363-21
1-409-529-41
1-414-753-91
1-216-295-91
FERRITE
FERRITE
INDUCTOR
INDUCTOR
SHORT
0µH
0µH
10µH
4.7µH
0
<TRANSISTOR>
Q102
Q103
Q104
Q105
Q106
8-729-230-49
8-729-230-49
8-729-230-49
1-801-806-11
1-801-806-11
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
TRANSISTOR DTC144EKA 0
TRANSISTOR DTC144EKA 0
Q107
8-729-216-22 TRANSISTOR 2SA1162-G
Ref.No.
Part No.
Description
Remark
R145
R146
1-216-114-00 RES,CHIP
1-216-073-00 RES,CHIP
510K
10K
5%
5%
1/10W
1/10W
R147
R148
R149
R150
R151
1-216-065-91
1-216-077-91
1-216-077-91
1-216-295-91
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
SHORT
4.7K
15K
15K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R152
R153
R154
R155
R156
1-216-053-00
1-216-121-91
1-216-085-00
1-216-073-00
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.5K
1M
33K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R157
R158
R159
R160
R161
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-049-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R162
R163
R164
R165
R166
1-216-097-91
1-216-097-91
1-216-085-00
1-216-089-91
1-216-091-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
100K
33K
47K
56K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R167
R168
R170
R171
R172
1-216-083-00
1-216-073-00
1-216-005-00
1-216-005-00
1-216-005-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
27K
10K
15
15
15
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R173
R174
R175
R176
R177
1-216-005-00
1-216-005-00
1-216-005-00
1-216-005-00
1-216-005-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15
15
15
15
15
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R178
R179
R180
R181
R182
1-216-005-00
1-216-005-00
1-216-005-00
1-216-005-00
1-216-077-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15
15
15
15
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R183
R184
R185
R186
R187
1-216-077-91
1-216-060-00
1-216-060-00
1-216-097-91
1-216-097-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15K
3K
3K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R189
R192
R193
R194
R195
1-216-295-91
1-216-073-00
1-216-053-00
1-216-025-91
1-216-057-00
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
0
10K
1.5K
100
2.2K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R197
R198
R199
1-216-073-00 RES,CHIP
1-216-053-00 RES,CHIP
1-216-073-00 RES,CHIP
10K
1.5K
10K
5%
5%
5%
1/10W
1/10W
1/10W
<RESISTOR>
R100
R101
R102
R103
R104
1-216-667-11
1-216-025-91
1-216-624-11
1-216-624-11
1-216-624-11
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
75
75
75
0.50%
5%
0.50%
0.50%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R105
R106
R107
R108
R109
1-216-113-00
1-216-113-00
1-216-295-91
1-216-049-91
1-216-049-91
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
470K
470K
0
1K
1K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R110
R111
R112
R113
R114
1-216-049-91
1-216-081-00
1-216-081-00
1-216-081-00
1-216-081-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R115
R116
R117
R118
R119
1-216-081-00
1-216-081-00
1-216-067-00
1-216-657-11
1-216-624-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
22K
22K
5.6K
1.8K
75
5%
5%
5%
0.50%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R120
R121
R122
R123
R124
1-216-091-00
1-216-063-91
1-216-067-00
1-216-067-00
1-216-077-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
56K
3.9K
5.6K
5.6K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R125
R127
R128
R129
R130
1-216-077-91
1-216-121-91
1-216-025-91
1-216-049-91
1-216-017-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
15K
1M
100
1K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R131
R133
R134
R135
R136
1-216-017-91
1-216-091-00
1-216-091-00
1-216-073-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47
56K
56K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
S101
S202
R137
R138
R139
R140
R141
1-216-025-91
1-216-089-91
1-216-025-91
1-216-025-91
1-216-089-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
47K
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
X101
X102
X103
R142
R143
R144
1-216-114-00 RES,CHIP
1-216-073-00 RES,CHIP
1-216-025-91 RES,CHIP
510K
10K
100
5%
5%
5%
1/10W
1/10W
1/10W
*************************************************************
6-8
<SWITCH>
1-762-984-11 SWITCH, PUSH (LAMP COVER)
1-771-897-11 SWITCH, MICRO (FILTER COVER)
<CRYSTAL>
1-781-163-11 VIBRATOR, OSCILLATOR (24MHz)
1-767-340-11 VIBRATOR, CRYSTAL (4MHz)
1-781-163-11 VIBRATOR, OSCILLATOR (24MHz)
VPL-CS1
GA
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
Remark
D611
D612
D613
D614
D615
8-719-071-97
8-719-106-31
8-719-071-97
8-719-073-37
8-719-053-50
DIODE P6KE350AG23
DIODE RD8.2M-T1B1
DIODE P6KE350AG23
DIODE P6KE300AG23
DIODE FCQ20A06
4-382-854-01 SCREW (M3X8), P, SW (+)
D616
D617
D618
D619
D620
8-719-051-96
8-719-053-50
8-719-071-97
8-719-106-31
8-719-071-97
DIODE FMG-G2CS
DIODE FCQ20A06
DIODE P6KE350AG23
DIODE RD8.2M-T1B1
DIODE P6KE350AG23
<CAPACITOR>
D621
D622
8-719-055-33 DIODE D1FL40
8-719-107-43 DIODE RD24M-B2
* A-1316-492-A GA COMPL
**********************
1-533-223-11
1-900-251-41
* 4-074-436-01
* 4-074-437-01
* 4-374-846-01
C601
C602
C603
C604
C608
! 1-113-907-51
! 1-115-166-11
! 1-113-907-51
1-135-449-11
1-107-906-11
C609
C610
C611
C612
C615
HOLDER, FUSE (F601)
CONNECTOR ASSY 3P
INSULATION PLATE (B)
INSULATION PLATE (A)
COVER, CAPACITOR,CAP TYPE
CERAMIC
FILM
CERAMIC
ELECT
ELECT
0.0022µF
0.22µF
0.0022µF
220µF
10µF
20%
20%
20%
20%
20%
250V
275V
250V
450V
50V
1-107-792-11
1-129-720-00
1-115-785-91
1-107-889-11
1-115-339-11
CERAMIC
FILM
ELECT
ELECT
CERAMIC CHIP
100PF
0.033µF
470µF
220µF
0.1µF
5%
5%
20%
20%
10%
1KV
630V
25V
25V
50V
C617
C618
C619
C620
C621
1-107-888-11
1-115-339-11
1-130-202-00
1-115-742-11
1-115-339-11
ELECT
CERAMIC CHIP
FILM
ELECT
CERAMIC CHIP
47µF
0.1µF
0.022µF
0.0027F
0.1µF
20%
10%
5%
20%
10%
25V
50V
400V
10V
50V
C623
C624
C625
C626
C627
1-107-909-11
1-115-339-11
1-115-339-11
1-163-003-11
1-164-492-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
0.1µF
0.1µF
330PF
0.15µF
20%
10%
10%
10%
10%
16V
50V
50V
50V
16V
C628
C629
C631
C632
C633
1-165-319-11
1-107-888-11
1-163-113-00
1-164-492-11
1-163-133-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
47µF
68PF
0.15µF
470PF
20%
5%
10%
5%
50V
25V
50V
16V
50V
C634
C635
C636
C637
C638
1-163-009-11
1-163-021-91
1-126-795-11
! 1-113-511-11
1-117-228-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
FILM
MYLAR
0.001µF
0.01µF
10µF
0.47µF
2.2µF
10%
10%
20%
20%
10%
50V
50V
50V
275V
450V
C671
C672
C673
C674
1-163-021-91
1-126-795-11
1-115-339-11
1-126-786-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01µF
10µF
0.1µF
47µF
10%
20%
10%
20%
50V
50V
50V
16V
<FUSE>
F601
! 1-576-233-11 FUSE (H.B.C.) (6.3A/250V)
<IC>
IC602
IC603
IC604
IC605
IC671
8-759-388-23
8-759-487-72
8-759-470-64
8-759-583-06
8-759-388-23
IC TL431BCDR2
IC TOP222Y-BB
IC TOP223Y-BB
IC FA5331M-TE1
IC TL431BCDR2
IC672
8-759-460-74 IC BA05FP-E2
<COIL>
<CONNECTOR>
CN601
CN604
CN605
CN606
* 1-691-960-11
* 1-794-043-11
* 1-564-706-11
* 1-774-249-11
! 8-719-066-75
8-719-060-06
8-719-055-30
8-719-055-30
8-719-066-76
D606
D607
D608
D609
D610
8-719-110-53
8-719-059-23
8-719-961-04
8-719-510-41
8-719-300-33
VPL-CS1
DIODE D6SB80
DIODE FSF10A60
DIODE D1FS4A-TA
DIODE D1FS4A-TA
DIODE TF861S
DIODE RD20ESB2
DIODE P6KE200AG23
DIODE RGP10J
DIODE D10SC9M
DIODE RU-3AM
! 1-431-419-11
1-416-754-21
1-406-976-11
1-413-090-00
TRANSFORMER,LINE FILTER
INDUCTOR
0µH
INDUCTOR
68µH
INDUCTOR
110µH
<PHOTO COUPLER>
PH601
PH602
PH603
8-749-010-64 PHOTO COUPLER
8-749-010-64 PHOTO COUPLER
8-749-010-64 PHOTO COUPLER
PC123F2
PC123F2
PC123F2
<IC LINK>
PS601
! 1-576-124-11 LINK, IC (2A)
<TRANSISTOR>
Q601
Q602
Q603
Q604
Q671
PIN, CONNECTOR (PC BOARD) 3P
CONNECTOR,BOARD TO BOARD 6P
PIN, CONNECTOR (SMALL TYPE) 4P
CONNECTOR, BOARD TO BOARD 10P
<DIODE>
D601
D602
D603
D604
D605
L601
L602
L603
L604
8-729-043-15
8-729-922-39
8-729-230-49
8-729-230-49
8-729-230-49
TRANSISTOR 2SK3013F-2
TRANSISTOR 2SD2144S-V
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
<RESISTOR>
R601
R602
R603
R604
R605
! 1-202-847-00
1-216-003-11
1-216-077-91
1-219-363-11
1-217-156-00
R606
R607
R608
R609
R610
R611
R613
R615
R617
SOLID
RES,CHIP
RES,CHIP
FUSIBLE
REGISTER
560K
12
15K
5.6
0.22
20%
5%
5%
5%
10%
1/2W
1/10W
1/10W
5W F
5W F
1-260-324-11
1-216-097-91
1-249-429-11
1-249-389-11
1-215-903-11
CARBON
RES,CHIP
CARBON
CARBON
METAL OXIDE
470
100K
10K
4.7
68K
5%
5%
5%
5%
5%
1/2W
1/10W
1/4W F
1/4W F
2W F
1-220-270-11
1-249-389-11
1-216-671-11
1-220-337-11
RES,CHIP
CARBON
METAL CHIP
RES,CHIP
390
4.7
6.8K
270K
5%
5%
0.50%
5%
1/2W
1/4W F
1/10W
1/2W
6-9
GA GBA GBB
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
Remark
<CAPACITOR>
R618
1-216-667-11 METAL CHIP
4.7K
0.50% 1/10W
R620
R621
R622
R623
R625
1-216-033-00
1-216-311-00
1-220-267-11
1-216-049-91
1-220-337-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
220
6.8
180
1K
270K
5%
5%
5%
5%
5%
1/10W
1/10W
1/2W
1/10W
1/2W
C676
C677
C678
C679
C680
1-126-382-11
1-115-339-11
1-115-339-11
1-126-796-11
1-115-339-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100µF
0.1µF
0.1µF
22µF
0.1µF
20%
10%
10%
20%
10%
16V
50V
50V
35V
50V
R626
R627
R628
R629
R630
1-216-075-00
1-216-025-91
1-216-689-11
1-215-927-00
1-215-927-00
RES,CHIP
RES,CHIP
RES,CHIP
METAL OXIDE
METAL OXIDE
12K
100
39K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
3W F
3W F
C681
C682
C683
C684
C718
1-115-784-11
1-115-339-11
1-115-339-11
1-124-589-11
1-115-339-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
270µF
0.1µF
0.1µF
47µF
0.1µF
20%
10%
10%
20%
10%
25V
50V
50V
16V
50V
R631
R632
R633
R634
R635
1-216-311-00
1-216-049-91
1-216-033-00
1-216-629-11
1-216-053-00
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
6.8
1K
220
120
1.5K
5%
5%
5%
0.50%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C719
1-126-789-11 ELECT
33µF
20%
25V
R636
R637
R638
R639
R640
1-216-085-00
1-216-101-00
1-216-073-00
1-216-659-11
1-216-659-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
33K
150K
10K
2.2K
2.2K
5%
5%
5%
0.50%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R641
R642
R643
R644
R645
1-216-655-11
1-220-335-11
1-220-337-11
1-220-336-11
1-220-337-11
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.5K
180K
270K
220K
270K
0.50%
5%
5%
5%
5%
1/10W
1/2W
1/2W
1/2W
1/2W
R646
R647
R648
R649
R650
1-220-335-11
1-220-335-11
1-216-075-00
1-216-025-91
1-216-005-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
180K
180K
12K
100
15
5%
5%
5%
5%
5%
1/2W
1/2W
1/10W
1/10W
1/10W
R651
R652
R653
R654
R671
1-216-687-11
1-216-689-11
1-216-065-91
1-216-667-11
1-216-603-11
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
33K
39K
4.7K
4.7K
10
0.50%
5%
5%
0.50%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R672
R673
R674
R675
R676
1-216-077-91
1-220-270-11
1-220-267-11
1-216-691-11
1-216-671-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
15K
390
180
47K
6.8K
5%
5%
5%
0.50%
0.50%
1/10W
1/2W
1/2W
1/10W
1/10W
R677
R678
R679
1-216-085-00 RES,CHIP
1-216-093-91 RES,CHIP
1-216-667-11 METAL CHIP
33K
68K
4.7K
5%
1/10W
5%
1/10W
0.50% 1/10W
<CONNECTOR>
CN671
CN674
CN675
CN676
1-794-042-11
1-564-707-11
* 1-564-705-11
* 1-564-705-11
CONNECTOR, BOARD TO BOARD
PIN, CONNECTOR (SMALL TYPE) 5P
PIN, CONNECTOR (SMALL TYPE) 3P
PIN, CONNECTOR (SMALL TYPE) 3P
<DIODE>
<TRANSFORMER>
T601
T602
! 1-435-199-11 TRANSFORMER,CONVERTER (SRT)
! 1-435-198-11 TRANSFORMER,CONVERTER (PIT)
<VARISTOR>
VD602
VD604
! 1-801-073-41 VARISTOR ERZV14D471
1-803-136-11 VARISTOR ZP260
*************************************************************
* A-1316-492-A GBA COMPL
**********************
1-533-223-11
* 4-074-436-01
* 4-074-437-01
* 4-374-846-01
4-382-854-01
6-10
HOLDER, FUSE (F601)
INSULATION PLATE (B)
INSULATION PLATE (A)
COVER, CAPACITOR,CAP TYPE
SCREW (M3X8), P, SW (+)
D672
D673
D674
D675
8-719-914-43
8-719-055-30
8-719-055-30
8-719-055-30
DIODE DAN202K
DIODE D1FS4A-TA
DIODE D1FS4A-TA
DIODE D1FS4A-TA
<IC>
IC673
IC704
8-759-650-39 IC LT1374IS8
8-759-388-31 IC PQ20VZ1U
<COIL>
L671
1-406-659-11 INDUCTOR
10µH
<TRANSISTOR>
Q672
Q673
8-729-230-49 TRANSISTOR 2SC2712-YG
8-729-230-49 TRANSISTOR 2SC2712-YG
<RESISTOR>
R680
R681
R682
R683
R686
1-216-049-91
1-216-025-91
1-216-073-00
1-216-025-91
1-216-089-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
100
10K
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R687
R688
R689
R694
R696
1-216-075-00
1-216-073-00
1-216-081-00
1-216-081-00
1-216-683-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
12K
10K
22K
22K
22K
5%
5%
5%
5%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R697
R698
R699
R700
R701
1-216-697-91
1-216-681-91
1-216-695-11
1-216-295-91
1-216-667-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
METAL CHIP
82K
18K
68K
0
4.7K
0.50% 1/10W
0.50% 1/10W
0.50% 1/10W
0.50% 1/10W
R716
R717
R718
R719
R720
1-216-683-11
1-216-675-91
1-216-665-11
1-216-665-11
1-216-675-91
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
3.9K
3.9K
10K
0.50%
0.50%
0.50%
0.50%
0.50%
R721
1-216-675-91 METAL CHIP
10K
0.50% 1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
VPL-CS1
GBB C
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
Remark
* A-1335-123-A C COMPL
**********************
*************************************************************
* A-1316-492-A GBB COMPL
**********************
<CAPACITOR>
1-533-223-11
* 4-074-436-01
* 4-074-437-01
* 4-374-846-01
4-382-854-01
HOLDER, FUSE (F601)
INSULATION PLATE (B)
INSULATION PLATE (A)
COVER, CAPACITOR,CAP TYPE
SCREW (M3X8), P, SW (+)
<CAPACITOR>
C701
C702
C740
C742
C776
1-115-339-11
1-126-789-11
1-117-354-91
1-117-316-91
1-126-786-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
C777
C778
1-124-589-11 ELECT
1-128-526-11 ELECT
0.1µF
33µF
330µF
470µF
47µF
10%
20%
20%
20%
20%
50V
25V
35V
25V
16V
47µF
100µF
20%
20%
16V
16V
<CONNECTOR>
CN702
CN706
CN707
* 1-774-246-11 CONNECTOR, BOARD TO BOARD 10P
* 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P
* 1-564-711-11 PIN, CONNECTOR (SMALL TYPE) 9P
<DIODE>
D715
D727
D728
D736
8-719-510-41
8-719-073-52
8-719-073-52
8-719-110-36
DIODE D10SC9M
DIODE D2FS6-TA
DIODE D2FS6-TA
DIODE RD13ESB2
<IC>
IC701
8-759-388-31 IC PQ20VZ1U
<COIL>
L702
L703
L707
1-406-977-61 INDUCTOR
1-416-208-11 INDUCTOR
1-412-525-31 INDUCTOR
100µH
150µH
10µH
<TRANSISTOR>
Q710
8-729-807-51 TRANSISTOR 2SD1623-S
<RESISTOR>
R706
R707
R781
R782
R784
1-216-653-11
1-216-679-11
1-216-671-11
1-216-675-91
1-218-235-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
1.2K
15K
6.8K
10K
82
0.50%
0.50%
0.50%
0.50%
5%
1/10W
1/10W
1/10W
1/10W
1/2W
R785
R787
R788
R789
1-220-274-11
1-220-274-11
1-220-274-11
1-220-274-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.2K
1.2K
1.2K
1.2K
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
*************************************************************
VPL-CS1
C801
C802
C803
C804
C805
1-135-346-21
1-128-400-11
1-128-400-11
1-117-681-11
1-128-400-11
TANTALUM
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
39µF
47µF
47µF
100µF
47µF
20%
20%
20%
20%
20%
16V
25V
25V
16V
25V
C807
C808
C812
C813
C814
1-115-340-11
1-126-205-11
1-115-340-11
1-164-004-11
1-126-205-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.22µF
47µF
0.22µF
0.1µF
47µF
10%
20%
10%
10%
20%
25V
6.3V
25V
25V
6.3V
C816
C817
C818
C819
C820
1-124-779-00
1-164-004-11
1-163-021-91
1-164-004-11
1-163-021-91
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10µF
0.1µF
0.01µF
0.1µF
0.01µF
20%
10%
10%
10%
10%
16V
25V
50V
25V
50V
C822
C824
C825
C826
C827
1-126-205-11
1-163-021-91
1-126-205-11
1-163-021-91
1-163-009-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
0.01µF
47µF
0.01µF
0.001µF
20%
10%
20%
10%
10%
6.3V
50V
6.3V
50V
50V
C828
C829
C830
C831
C832
1-164-004-11
1-163-021-91
1-126-391-11
1-109-982-11
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.01µF
47µF
1µF
0.01µF
10%
10%
20%
10%
10%
25V
50V
6.3V
10V
50V
C833
C834
C836
C838
C840
1-163-021-91
1-163-021-91
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01µF
0.01µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
50V
50V
25V
25V
25V
C841
C842
C843
C845
C846
1-124-779-00
1-124-779-00
1-124-779-00
1-163-009-11
1-163-009-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
10µF
10µF
10µF
0.001µF
0.001µF
20%
20%
20%
10%
10%
16V
16V
16V
50V
50V
C850
C851
C852
C853
C854
1-163-021-91
1-164-004-11
1-163-009-11
1-109-982-11
1-126-205-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.01µF
0.1µF
0.001µF
1µF
47µF
10%
10%
10%
10%
20%
50V
25V
50V
10V
6.3V
C855
C856
C857
C858
C859
1-109-982-11
1-109-982-11
1-109-982-11
1-164-004-11
1-126-205-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
1µF
1µF
1µF
0.1µF
47µF
10%
10%
10%
10%
20%
10V
10V
10V
25V
6.3V
C860
C861
C862
C863
C864
1-164-004-11
1-109-982-11
1-164-004-11
1-109-982-11
1-126-205-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1µF
1µF
0.1µF
1µF
47µF
10%
10%
10%
10%
20%
25V
10V
25V
10V
6.3V
C865
C867
C868
C869
C870
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-128-400-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1µF
0.1µF
0.1µF
0.1µF
47µF
10%
10%
10%
10%
20%
25V
25V
25V
25V
25V
C871
C873
C874
C877
C878
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.1µF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C879
1-163-227-11 CERAMIC CHIP 10PF
0.5PF 50V
6-11
C
Ref.No.
Part No.
Description
Remark
Ref.No.
Part No.
Description
Remark
C960
C961
C962
1-117-370-11 CERAMIC CHIP 10µF
1-109-982-11 CERAMIC CHIP 1µF
1-164-004-11 CERAMIC CHIP 0.1µF
10%
10%
10V
10V
25V
C963
C964
C965
C966
C967
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
0.1µF
0.1µF
0.1µF
0.01µF
10%
10%
10%
10%
10%
25V
25V
25V
25V
50V
C968
C969
C970
C971
1-164-004-11
1-126-205-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
47µF
0.1µF
0.1µF
10%
20%
10%
10%
25V
6.3V
25V
25V
C880
C881
C882
C883
1-128-400-11
1-164-004-11
1-117-681-11
1-164-004-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47µF
0.1µF
100µF
0.1µF
20%
10%
20%
10%
25V
25V
16V
25V
C886
C887
C888
C890
C891
1-164-004-11
1-126-205-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1µF
47µF
0.1µF
0.1µF
0.1µF
10%
20%
10%
10%
10%
25V
6.3V
25V
25V
25V
C892
C893
C894
C895
C896
1-163-009-11
1-163-009-11
1-164-005-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001µF
0.001µF
0.47µF
0.1µF
0.1µF
10%
10%
10%
10%
50V
50V
25V
25V
25V
C897
C898
C899
C900
C902
1-128-400-11
1-128-400-11
1-164-004-11
1-164-004-11
1-164-004-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
47µF
0.1µF
0.1µF
0.1µF
20%
20%
10%
10%
10%
25V
25V
25V
25V
25V
C904
C905
C906
C907
C909
1-163-227-11
1-163-227-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
10PF
0.1µF
0.1µF
0.1µF
0.5PF
0.5PF
10%
10%
10%
50V
50V
25V
25V
25V
C911
C912
C913
C914
C915
1-164-004-11
1-164-004-11
1-128-400-11
1-117-681-11
1-128-400-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
0.1µF
0.1µF
47µF
100µF
47µF
10%
10%
20%
20%
20%
25V
25V
25V
16V
25V
C916
C917
C918
C919
C920
1-117-681-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100µF
0.1µF
0.1µF
0.1µF
0.1µF
20%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C923
C925
C926
C927
C928
1-126-205-11
1-164-004-11
1-126-205-11
1-164-004-11
1-164-004-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
47µF
0.1µF
47µF
0.1µF
0.1µF
20%
10%
20%
10%
10%
6.3V
25V
6.3V
25V
25V
C931
C932
C933
C934
C935
1-164-004-11
1-164-004-11
1-164-005-11
1-164-005-11
1-104-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
0.1µF
0.1µF
0.47µF
0.47µF
2.2µF
10%
10%
20%
25V
25V
25V
25V
20V
C936
C937
C938
C939
C940
1-109-982-11
1-128-394-11
1-124-779-00
1-113-985-11
1-109-982-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
TANTAL. CHIP
CERAMIC CHIP
1µF
220µF
10µF
10µF
1µF
10%
20%
20%
20%
10%
10V
10V
16V
20V
10V
FB801
FB802
FB803
FB804
FB805
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0µH
0µH
0µH
0µH
0µH
C941
C942
C943
C944
C945
1-128-394-11
1-126-396-11
1-164-004-11
1-104-915-11
1-104-760-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
220µF
47µF
0.1µF
2.2µF
0.047µF
20%
20%
10%
20%
10%
10V
16V
25V
20V
50V
FB806
FB807
FB808
FB809
FB810
1-414-234-22
1-414-234-22
1-414-234-22
1-414-950-21
1-414-950-21
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
FERRITE
FERRITE
0µH
0µH
0µH
0µH
0µH
C946
C947
C948
C949
C950
1-104-760-11
1-115-340-11
1-115-340-11
1-117-681-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.047µF
0.22µF
0.22µF
100µF
0.1µF
10%
10%
10%
20%
10%
50V
25V
25V
16V
25V
FB811
FB812
FB813
FB814
FB815
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0µH
0µH
0µH
0µH
0µH
C951
C952
C953
C954
C955
1-163-021-91
1-113-985-11
1-163-021-91
1-163-021-91
1-124-779-00
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.01µF
10µF
0.01µF
0.01µF
10µF
10%
20%
10%
10%
20%
50V
20V
50V
50V
16V
FB816
FB817
FB818
FB819
FB820
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
1-414-234-22
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
0µH
0µH
0µH
0µH
0µH
C958
C959
1-117-370-11 CERAMIC CHIP 10µF
1-117-370-11 CERAMIC CHIP 10µF
10V
10V
FB821
FB822
1-414-234-22 INDUCTOR CHIP
1-414-234-22 INDUCTOR CHIP
0µH
0µH
<CONNECTOR>
6-12
CN801
CN802
CN803
CN804
CN805
* 1-793-798-21
* 1-691-551-11
1-774-932-21
* 1-580-789-21
* 1-580-055-21
CONNECTOR, BOARD TO BOARD
PIN, CONNECTOR (SMD)
8P
CONNECTOR, FFC/FPC (ZIF)
32P
PIN, CONNECTOR (SMD)
6P
PIN, CONNECTOR (SMD)
2P
CN806
CN807
CN808
CN809
CN810
* 1-580-056-21
1-569-775-11
* 1-764-007-11
* 1-569-775-21
* 1-691-551-11
PIN, CONNECTOR (SMD)
PIN, CONNECTOR (SMD)
PIN, CONNECTOR (SMD)
PIN, CONNECTOR (SMD)
PIN, CONNECTOR (SMD)
3P
5P
12P
5P
8P
CN811
CN812
CN813
CN814
1-766-479-21
1-766-479-21
1-766-479-21
* 1-580-057-11
CONNECTOR, FFC/FPC (ZIF)
CONNECTOR, FFC/FPC (ZIF)
CONNECTOR, FFC/FPC (ZIF)
PIN, CONNECTOR (SMD)
24P
24P
24P
4P
<DIODE>
D801
D802
D803
D804
D805
8-719-976-99
8-719-976-99
8-719-976-99
8-719-976-99
8-719-976-99
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
D806
D807
D812
D813
D814
8-719-976-99
8-719-976-99
8-719-976-99
8-719-976-99
8-719-976-99
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
DIODE DTZ5.1B
<FERRITE BEAD>
VPL-CS1
C
Ref.No.
FB823
FB824
Part No.
Description
Remark
1-414-234-22 INDUCTOR CHIP
1-414-234-22 INDUCTOR CHIP
0µH
0µH
Ref.No.
Q816
Q817
1-239-899-21
1-234-011-11
1-234-011-11
1-234-011-11
Description
Remark
1-801-806-11 TRANSISTOR DTC144EKA0
8-729-112-65 TRANSISTOR 2SA1462-Y33
<RESISTOR>
<FILTER>
FL801
FL802
FL803
FL804
Part No.
FILTER, CHIP
FILTER, EMI
FILTER, EMI
FILTER, EMI
EMI
<IC>
IC801
IC802
IC803
IC804
IC805
8-759-259-77
8-759-460-81
8-759-584-86
8-759-523-81
8-759-660-42
IC PQ20VZ5U
IC BA12FP-E2
IC M52749FP-TP
IC TC74VHC08FT(EL)
IC THC63LVDF84A-T
IC806
IC807
IC808
IC809
IC810
8-759-645-13
8-719-985-01
8-759-491-46
8-759-658-73
8-759-491-46
IC ADV7123KST140
DIODE LM385M-1.2
IC TC74VHCT04AFT(EL)
IC ISPLSI1016E-80LT44-SX1697
IC TC74VHCT04AFT(EL)
IC811
IC812
IC813
IC814
IC815
8-759-482-35
8-759-592-44
8-759-064-36
8-759-544-55
8-752-080-99
IC MC100ELT20DR2
IC TC7SZ04FU(TE85R)
IC MB88346BPFV
IC MAX4066CEE#NAME?
IC CXA2112R
IC817
IC818
IC819
IC820
IC821
8-752-080-99
8-752-080-99
8-759-702-02
8-752-091-06
8-759-702-02
IC CXA2112R
IC CXA2112R
IC NJM062M
IC CXA1846BN-T4
IC NJM062M
IC822
8-759-491-46 IC TC74VHCT04AFT(EL)
R801
R802
R803
R804
R805
1-216-073-00
1-216-682-11
1-216-673-11
1-216-295-91
1-216-065-91
RES,CHIP
METAL CHIP
METAL CHIP
SHORT
RES,CHIP
10K
20K
8.2K
0
4.7K
5%
1/10W
0.50% 1/10W
0.50% 1/10W
R806
R807
R809
R810
R811
1-216-644-11
1-216-017-91
1-216-295-91
1-216-017-91
1-216-017-91
METAL CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
510
47
0
47
47
0.50% 1/10W
5%
1/10W
5%
5%
1/10W
1/10W
R812
R813
R815
R816
R817
1-216-017-91
1-216-017-91
1-216-651-11
1-216-025-91
1-216-049-91
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
47
47
1K
100
1K
5%
5%
0.50%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R820
R821
R822
R823
R824
1-216-025-91
1-216-661-11
1-216-065-91
1-216-065-91
1-216-025-91
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
2.7K
4.7K
4.7K
100
5%
0.50%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R825
R826
R827
R828
R829
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-089-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R830
R831
R832
R833
R836
1-216-009-91
1-216-624-11
1-216-624-11
1-216-113-00
1-216-025-91
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
22
75
75
470K
100
5%
0.50%
0.50%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R837
R838
R839
R841
R842
1-216-049-91
1-216-295-91
1-216-049-91
1-216-624-11
1-216-065-91
RES,CHIP
SHORT
RES,CHIP
METAL CHIP
RES,CHIP
1K
0
1K
75
4.7K
5%
1/10W
R843
R844
R845
R846
R847
1-216-037-00
1-216-037-00
1-216-295-91
1-216-037-00
1-216-037-00
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
330
330
0
330
330
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R848
R849
R850
R851
R852
1-216-649-11
1-216-662-11
1-216-025-91
1-216-025-91
1-216-025-91
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
820
3K
100
100
100
0.50%
0.50%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R853
R854
R855
R856
R857
1-216-295-91
1-216-295-91
1-216-017-91
1-216-017-91
1-216-017-91
SHORT
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
0
0
47
47
47
5%
5%
5%
1/10W
1/10W
1/10W
R858
R859
R860
R861
R862
1-216-017-91
1-216-049-91
1-216-017-91
1-216-017-91
1-216-017-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47
1K
47
47
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R863
R864
R865
R866
R867
1-216-295-91
1-216-049-91
1-216-295-91
1-216-025-91
1-216-017-91
SHORT
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
0
1K
0
100
47
5%
1/10W
5%
5%
1/10W
1/10W
R868
1-216-025-91 RES,CHIP
100
5%
1/10W
5%
1/10W
<COIL>
L801
L802
L803
L804
L806
1-410-393-11
1-410-381-11
1-414-752-11
1-414-752-11
1-410-369-11
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR
INDUCTOR
INDUCTOR CHIP
100µH
10µH
2.2µH
2.2µH
1µH
L807
L808
L809
L810
L811
1-410-369-11
1-410-369-11
1-410-369-11
1-410-369-11
1-410-369-11
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
1µH
1µH
1µH
1µH
1µH
L812
L813
L814
1-410-377-31 INDUCTOR CHIP
1-414-752-11 INDUCTOR
1-469-524-91 INDUCTOR
4.7µH
2.2µH
4.7µH
<TRANSISTOR>
Q801
Q802
Q803
Q804
Q805
8-729-112-65
8-729-216-22
8-729-216-22
8-729-013-28
8-729-013-28
TRANSISTOR 2SA1462-Y33
TRANSISTOR 2SA1162-G
TRANSISTOR 2SA1162-G
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
Q806
Q807
Q808
Q809
Q810
8-729-013-28
8-729-013-28
8-729-013-28
8-729-013-28
8-729-216-22
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR HN1B01FU-TE85R
TRANSISTOR 2SA1162-G
Q811
Q812
Q813
Q814
Q815
8-729-230-49
1-801-806-11
1-801-806-11
8-729-112-65
8-729-112-65
TRANSISTOR 2SC2712-YG
TRANSISTOR DTC144EKA0
TRANSISTOR DTC144EKA0
TRANSISTOR 2SA1462-Y33
TRANSISTOR 2SA1462-Y33
VPL-CS1
5%
1/10W
0.50% 1/10W
5%
1/10W
6-13
C
Ref.No.
Part No.
Description
Remark
R869
R870
R871
R872
1-216-017-91
1-216-025-91
1-216-017-91
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
47
100
47
0
5%
5%
5%
1/10W
1/10W
1/10W
R873
R874
R875
R876
R877
1-216-025-91
1-216-295-91
1-216-295-91
1-216-009-91
1-216-037-00
RES,CHIP
SHORT
SHORT
RES,CHIP
RES,CHIP
100
0
0
22
330
5%
1/10W
5%
5%
1/10W
1/10W
R878
R879
R880
R881
R882
1-216-037-00
1-216-009-91
1-216-073-00
1-216-295-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
330
22
10K
0
100
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R883
R884
R885
R887
R889
1-216-295-91
1-216-067-00
1-216-025-91
1-216-077-91
1-216-025-91
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
0
5.6K
100
15K
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R890
R891
R892
R893
R894
1-216-025-91
1-216-025-91
1-216-065-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
4.7K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R895
R896
R900
R901
R902
1-216-025-91
1-216-065-91
1-216-295-91
1-216-041-00
1-216-025-91
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
100
4.7K
0
470
100
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R903
R904
R905
R906
R907
1-216-025-91
1-216-025-91
1-216-025-91
1-216-295-91
1-216-065-91
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
100
100
100
0
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R908
R909
R910
R911
R912
1-216-041-00
1-216-065-91
1-216-295-91
1-216-041-00
1-216-041-00
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
470
4.7K
0
470
470
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R913
R914
R915
R916
R917
1-216-041-00
1-216-685-11
1-216-295-91
1-216-295-91
1-216-001-00
RES,CHIP
METAL CHIP
SHORT
SHORT
RES,CHIP
470
27K
0
0
10
5%
1/10W
0.50% 1/10W
5%
1/10W
R918
R919
R920
R921
R922
1-216-057-00
1-216-001-00
1-216-025-91
1-216-298-00
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
2.2K
10
100
2.2
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R923
R924
R925
R926
R927
1-216-001-00
1-216-057-00
1-216-298-00
1-216-001-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10
2.2K
2.2
10
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R929
R930
R931
R932
R933
1-216-001-00
1-216-001-00
1-216-295-91
1-216-073-00
1-216-057-00
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
10
10
0
10K
2.2K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R934
R935
R936
R937
R938
1-216-025-91
1-216-298-00
1-216-295-91
1-216-057-00
1-216-298-00
RES,CHIP
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
100
2.2
0
2.2K
2.2
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R941
R942
1-216-017-91 RES,CHIP
1-216-017-91 RES,CHIP
47
47
5%
5%
1/10W
1/10W
6-14
Ref.No.
Part No.
Description
Remark
R943
R944
R945
1-216-295-91 SHORT
1-216-057-00 RES,CHIP
1-216-025-91 RES,CHIP
0
2.2K
100
R946
R947
R948
R949
R950
1-216-298-00
1-216-295-91
1-216-057-00
1-216-298-00
1-216-685-11
RES,CHIP
SHORT
RES,CHIP
RES,CHIP
METAL CHIP
R951
R952
R953
R954
R955
1-216-685-11
1-216-295-91
1-216-295-91
1-216-001-00
1-216-001-00
R956
R957
R958
R959
R960
5%
5%
1/10W
1/10W
2.2
0
2.2K
2.2
27K
5%
1/10W
METAL CHIP
SHORT
SHORT
RES,CHIP
RES,CHIP
27K
0
0
10
10
0.50% 1/10W
5%
5%
1/10W
1/10W
1-216-001-00
1-216-001-00
1-216-001-00
1-216-001-00
1-216-001-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10
10
10
10
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R961
R962
R963
R964
R965
1-216-001-00
1-216-001-00
1-216-001-00
1-216-073-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10
10
10
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R966
R967
R968
R969
R970
1-216-001-00
1-216-001-00
1-216-073-00
1-216-073-00
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
10
10
10K
10K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R971
R972
R973
R975
R976
1-216-089-91
1-216-295-91
1-216-071-00
1-216-295-91
1-216-071-00
RES,CHIP
SHORT
RES,CHIP
SHORT
RES,CHIP
47K
0
8.2K
0
8.2K
5%
1/10W
5%
1/10W
5%
1/10W
R977
R978
R979
R980
R981
1-216-089-91
1-217-671-11
1-217-671-11
1-216-067-00
1-216-067-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
47K
1
1
5.6K
5.6K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R982
R983
R984
R985
R986
1-216-057-00
1-216-057-00
1-216-033-00
1-216-033-00
1-216-295-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
2.2K
2.2K
220
220
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R988
R989
R990
R991
R992
1-216-295-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-053-00
SHORT
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
0
100
100
100
1.5K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R993
R994
R995
R996
R997
1-216-061-00
1-216-097-91
1-216-073-00
1-216-649-11
1-216-662-11
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
3.3K
100K
10K
820
3K
5%
5%
5%
0.50%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R998
R999
R1000
R1001
R1002
1-216-649-11
1-216-662-11
1-216-041-00
1-216-041-00
1-216-041-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
820
3K
470
470
470
0.50%
0.50%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1003
R1004
R1005
R1006
R1007
1-216-057-00
1-216-057-00
1-216-057-00
1-216-057-00
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
2.2K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1008
R1009
R1010
1-216-057-00 RES,CHIP
1-216-631-11 METAL CHIP
1-216-631-11 METAL CHIP
2.2K
150
150
5%
1/10W
0.50% 1/10W
0.50% 1/10W
5%
1/10W
5%
1/10W
0.50% 1/10W
VPL-CS1
C H NF
Ref.No.
Part No.
Description
Remark
R1011
R1012
1-216-631-11 METAL CHIP
1-216-073-00 RES,CHIP
150
10K
0.50% 1/10W
5%
1/10W
R1013
R1014
R1015
R1016
R1017
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
1-216-025-91
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1018
R1019
R1020
R1021
R1022
1-216-009-91
1-216-295-91
1-216-295-91
1-216-043-91
1-216-061-00
RES,CHIP
SHORT
SHORT
RES,CHIP
RES,CHIP
22
0
0
560
3.3K
5%
1/10W
5%
5%
1/10W
1/10W
Ref.No.
TH801
TH802
1-808-656-11 THERMISTOR
1-808-656-11 THERMISTOR
<TEST PIN>
Description
Remark
<TRANSISTOR>
Q001
<THERMISTOR>
Part No.
8-729-027-38 TRANSISTOR DTA144EKA0
<RESISTOR>
R001
R002
R003
R004
R005
1-216-073-00
1-216-073-00
1-216-049-91
1-216-083-00
1-216-075-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
10K
10K
1K
27K
12K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R006
R007
R008
R009
R010
1-216-069-00
1-216-063-91
1-216-059-00
1-216-057-00
1-216-053-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
6.8K
3.9K
2.7K
2.2K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R011
R012
R013
R014
R015
1-216-055-00
1-216-037-00
1-216-059-00
1-216-057-00
1-216-053-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1.8K
330
2.7K
2.2K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R016
1-216-055-00 RES,CHIP
1.8K
5%
1/10W
TP801
TP802
TP803
TP804
TP805
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
TP806
TP807
TP808
TP809
TP810
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
S001
S002
S003
S004
S005
1-771-105-11
1-771-105-11
1-771-105-11
1-771-105-11
1-771-105-11
SWITCH, TACTILE (LEFT)
SWITCH, TACTILE (RIGHT)
SWITCH, TACTILE (DOWN)
SWITCH, TACTILE (UP)
SWITCH, TACTILE (ENTER)
TP811
TP812
TP813
TP814
TP815
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
1-535-757-11
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
CHIP, CHECKER
S006
S007
S008
S009
S010
1-771-105-11
1-771-105-11
1-771-105-11
1-771-105-11
1-771-105-11
SWITCH, TACTILE (MENU)
SWITCH, TACTILE (INPUT)
SWITCH, TACTILE (POWER)
SWITCH, TACTILE (APA)
SWITCH, TACTILE (VOL+)
TP816
TP817
1-535-757-11 CHIP, CHECKER
1-535-757-11 CHIP, CHECKER
S011
S012
1-771-105-11 SWITCH, TACTILE (VOL–)
1-771-105-11 SWITCH, TACTILE (RESET)
<SWITCH>
*************************************************************
*************************************************************
* A-1390-984-A NF MOUNT
**********************
* A-1375-195-A H COMPL
**********************
<CAPACITOR>
<CAPACITOR>
C001
1-164-004-11 CERAMIC CHIP 0.1µF
10%
25V
C071
* 1-764-007-11 PIN, CONNECTOR (SMD) 12P
CN071
20%
20V
* 1-580-056-21 PIN, CONNECTOR (SMD) 3P
<IC>
<DIODE>
D001
D002
D003
D004
D005
8-719-045-61
8-719-045-61
8-719-045-53
8-719-914-43
8-719-914-43
DIODE SEC1901C (LAMP-LED)
DIODE SEC1901C (TEMP-LED)
DIODE SEC1801C (POWER-SAVE)
DIODE DAN202K
DIODE DAN202K
D006
D007
D008
D009
D010
8-719-914-43
8-719-914-43
8-719-045-51
8-719-914-44
8-719-914-44
DIODE DAN202K
DIODE DAN202K
DIODE SEC2422C (POWER/STBY)
DIODE DAP202K
DIODE DAP202K
D011
D012
8-719-914-44 DIODE DAP202K
8-719-914-44 DIODE DAP202K
VPL-CS1
10µF
<CONNECTOR>
<CONNECTOR>
CN001
1-113-985-11 TANTAL. CHIP
IC071
8-749-012-17 IC RS-140-T
<RESISTOR>
R071
R072
1-216-017-91 RES,CHIP
1-216-025-91 RES,CHIP
47
100
5%
5%
1/10W
1/10W
*************************************************************
6-15
Ref.No.
Part No.
Description
Remark
MISCELLANEOUS
**********************
A-150-163-6A
! 1-251-382-12
1-468-457-11
1-500-082-11
1-500-657-11
1-529-544-11
1-763-172-11
1-763-474-11
1-900-222-47
1-900-251-42
OPTICS BLOCK ASSY
INLET, AC 3P(WITH NOISE FILTE)
POWER, LAMP
CLAMP, SLEEVE FERRITE
CORE, FERRIET
SPEAKER (3.6CM)
FAN, DC
FAN
CONNECTOR ASSY 2P
CONNECTOR ASSY, MINI MICRO 4P
*************************************************************
ACCESSORIES
**********************
! 1-534-827-14 CORD, POWER (7A/125V)
! 1-777-649-11 CORD, POWER (10A/250V)
! 1-782-929-11 CORD, POWER SUPPLY (BS 3P)
(10A/250V)
1-418-804-11 REMOTE COMMANDER (RM-PJM1)
1-790-081-21 CABLE, USB
4-074-278-11 OPERATING, INSTRUCTIONS
(ENGLISH/FRENCH/SPANISH)
4-074-278-21 OPERATING, INSTRUCTIONS
(GERMAN/ITALIAN)
4-074-279-01 QUICK REFERENCE CARD (ENGLISH/
FRENCH/SPANISH/GERMAN/ITALIAN/
CHINESE)
* 4-074-444-01 BAG, CARRY
4-074-717-01 FILTER
9-885-000-19 BATTERY COVER (FOR RM-PJM1)
6-16
VPL-CS1
OVERALL
OVERALL
Section 7
Block Diagrams
B
MAIN CPU,A/D CONVERTER,SCAN CONVERTER,SDRAM,
LVDS RECEIVER,RGB INPUT,SYNC SEP
C
LCD DRIVER,RGB AMP,AUDIO AMP,
12CH DAC,TIMING GENERATER
1
M.OUT
IC806
IC404
INPUT-A
R-Y,Y,B-Y
V-R,V-G,V-B
VIDEO
SW
IC409
R,G,B
A/D
CONV.
IC417
R AD,G AD B,AD
G SYNC
SEPA.
LDVS
RECEIVER
IC805
TA,TB,TC,TD
RA,RB,RC,RD
D/A
CONV.
LDVS
RECEIVER
IC414
IC415
IC416
IC406
IC407
Y
IC413
R,G,B
SCAN
CONV.
D/A
CONV.
IC427
MAIN CPU
IC809
SDRAM
IC402
IC815
IC817
IC818
IC803
TIMING
GEN.
PLD
R DA,G DA,B DA
R,G,B
RGB
AMP
LCD
PANEL
LCD
DRIVER
IC808
IC810
INV.
IC424
INV
SW
OSD
IC813
SDAT
HSI,VSI
12CH D/A
CONV.
FLASH
LAMP ON
LAMP
2
RXD
TXD
VISCA
H(KEY
INPUT,LED)
LED
KEY
IC827
IC819,821
VOLUME
AUDIO
AMP
A-L,A-R
SP
L,R
KEY
MATRIX
CONTROL
POWER CONT
FAN CONT
LAMPC,FANC,SIRES
U-DA,U-CL
R-Y,Y,B-Y
V-R,V-G,V-B
3
GA,GBA,GBB
DC-DC CONVERTER
FAN DRIVE
SW REG.
&
DC-DC CONV.
POWER CONT
FAN CONT
QA
VIDEO INPUT,MOUSE CONNECTOR,
A/B USB CONNECTOR
BA
CN416
4
IC301
3
FAN+B
C,Y,S
IC605
AC IN
FAN1
1
POWER-FACTOR
REGULATING
CONTROL
COLOR DECODER,
RGB DECODER,D COMB
IC221
C,Y
C,Y
AD
COLOR
DECODER
2
DIGITAL
COMB
FILTER
IC201
J101
S
VIDEO
VIDEO
D/A
CONV.
FAN2
IC271
SUB+5V
AUDIO+B
+16.5V
R-Y,Y,B-Y
V-R,V-G,V-B
RGB
DECODER
A-L,A-R
NF
4
A-R
A-L
FRONT SIRCS
RECEIVE
AUDIO IN
IC071
IC123
SIRCS-NF
IR
RECEIVER
IC121
SIRES
REMOTE
SW
SIRCS
RECEIVER
USB5V
IC127
USB HUB CTRL
IC122
CN122
DAT/R1
MOUSE
CONT.
DS2+,DS2-
J122
US+,US-
IC128
USB POWER
SUPP
J121
DS1+,DS1-
5
LAMPC
IC125
USB PJ
CTRL
IC124
DS3+,DS3FANC
RESET
OVERALL BLOCK
7-1
VPL-CS1
A
B
C
D
7-1
E
F
G
H
NF, QA
QA(VIDEO
INPUT,MOUSE CONNECTOR,USB CONNECTOR,USB CONTROL)
Q102
C
BUFFER
S-C
Y
Q103
Y
BUFFER
S-Y
CN416
S-VIDEO
3
2
CN104
C
1
4
1
NF, QA
S
C
Y
S-IN
S SEL
VIDEO
Q104
CV
BUFFER
J101
VIDEO
C-V
F-DA
F-CL
CN101
IC101
3.3V REG
1
2
A
SUB +5V
I
TO GBB BOARD
CN707
O
IC102
3.3V REG
I
1
5
6
2
+16.5V
I
A +3.3V
F+5V
O
SDA
G
IC103
9V REG
CN102
2
5V-3
G
TO GA BOARD
CN605
B
SUB +3.3V
SCL
A +9V
IC104
5V REG
O
G
+6V
AUDIO +B
I
IC106
5V REG
A +5V
O
I
D +5V
O
V-VD
IC105
3.3V REG
2 VIN
D +3.3V
V-HD
VSW 3
G
G
V-CLP
15K-CS
IC107
PAL-V
5
6
7
2
3
1
B-Y
R-Y
Y
IC108
NF(FRONT
SIRCS RECEIVE)
CN071
3
IC071
XXXXXX
VCC
OUT
SUB +5V
SIRCS-NF
1
2
3
2
1
5
6
7
V-G
V-B
IC123
REMOTE SW
SUB +5V
SIRCS-NF
CN103
SDA
2 IRIN1
3 IRIN2
5V
IC121
SIRCS RECEIVE
VCC OUT
SIRCS
SCL
IROUT 5
NF ON
NR ON
7 IREN1
6 IREN2
F+5V
F-DA
USB5V
CLK
MOUSE
F-CL
IC122
MOUSE CONTROLLER
CN122
10 PB7
IC127
USB HUB CONTROL
28 PA1
24 PA2
DAT/R1
DS2DS2+
USB- 32
USB+ 31
13
12
2 X2
USUS+
X101
24MHz
TP102
US-
3 X1
8
7
41
40
33
32
IC128
USB POWER SUPP
1
4
2
3
CTL2
CTL1
FLG2
FLG1
USB5V
S202
OUT2 8
OUT1 5
IC125
USB RJ CONTROL
USB REQ
7 PC0
4
DS1DS1+
US3.3V-1
TP101
J122 US+
B TYPE
USB
I
TO BA BOARD
CN201
5V
CN123
1
2
V-R
A19
B19
A21
B21
A15
B15
A23
B23
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A16
B16
A17
B17
A25
B25
A27
B27
A29
B29
A31
B31
A33
B33
A35
B35
DS3DS3+
10
9
U-DA
U-CL
28 PA1
24 PA2
Q105
15
14
42
SW
S101
PWR PROT
SIRES
NR ON
NF ON
U-DA
U-CL
LAMPC
FAN-C
A-R
A-GND
DS3USBDM 31
DS3+
USBDP 32
A-L
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A31
B31
B28
B29
A28
A29
A27
B27
A33
B33
A34
B34
A35
B35
G
TO B BOARD
CN401
8 RESET
US+
26
2 OSCOUT
X102
4MHz
3.3V-1
CN105
X103
24MHz
25
USB REQ
R-Y
3 OSCIN
Q106,107
SW
6
Y
J121
A TYPE
USB
B-Y
1
2
3
4
DS1DS1+
5V
IC124
RESET
2 VDD
V-R
OUT 1
V-G
V-B
J102
5
A-R
A-L
A-GND
AUDIO IN
PAL-V
15K-CS
V-HD
V-VD
V-CLP
A25
A2
B2
A4
B4
A6
B6
A8
B8
A10
B10
A12
B12
A14
B14
A16
B16
A18
B18
A19
B19
A20
B20
H
TO B BOARD
CN402
NF, QA BLOCK
7-2
A
B
C
D
7-2
VPL-CS1
E
F
G
H
BA
BA
1
BA(COLOR
A25
B25
A27
B27
A29
B29
Q271
B-Y
B-Y
BUFFER
R-Y
Q272
R-Y
BUFFER
Y
37 BY2-IN
38 RY2-IN
Q273
Y
BUFFER
Y1-IN 35
RY1-IN 34
BY1-IN 33
VY
VR-Y
VB-Y
39 Y2-IN
TP271
V-R
A31
B31
A33
B33
A35
B35
IC271
RGB DECODER
DECODER,RGB DECODER,D COMB)
CN201
TP272
V-G
2
TP273
V-B
V-R
44 R-OUT
45 G-OUT
46 B-OUT
V-G
V-B
SCL
SDA
14 SCL
13 SDA
YUV-SW 30
IC301
COLOR DECODER
A19
B19
A21
B21
A23
B23
A16
B16
A17
B17
C
S-C
43 C2
Y
S-Y
VIDEO
VIDEO
15K-CS
15K-CS
44 CVBS/Y2
CR OUT 23
CB OUT 22
Y OUT 21
VR-Y
VB-Y
VY
1 CVBS/Y1
CVBS OUT(2VPPP) 3
19 Y1
BUFFER
PALV
PAL-V
Q229
Y
BUFFER
41 CVBS/Y3
COMB Y 5
I
SCL
SDA
TO QA BOARD
CN104
1
INV
Q227
C
BUFFER
4 VS
COMB C/FORCED S 7
Q303
V-HD
A14
B14
V-CLP
6
BUFFER
6
2 ADIN
3
Q228
Y
BUFFER
1
9 AYO
13 SCL
14 SDA
V-VD
A13
B13
Q222
FL223
FILTER
Q302
A12
B12
IC221
DIGITAL COMB FILTER
FL221
FILTER
Q221
INV
FL222
FILTER
6
Q226
C
BUFFER
1
7 ACO
9 HS
IC302
SFC OUT 46
1
3
4
37 FIN
10 SCP
38 XTAL
X301
16.2MHz
IC201
D/A CONVERTER
INPUTA/VIDEO
A15
B15
A11
B11
A10
B10
A7
B7
A8
B8
S-IN
A9
B9
F+5V
INPUT/VIDEO
NTPL1
10 SW3
9 SW2
1 SW1
SCL
SCL
SDA
SDA
15 SDL
14 SDA
DAC 4 3
DAC 0 7
DAC 1 6
DAC 2 5
VEH 3
VEH 2
VEH 1
4
20 VEH 3
21 VEH 2
22 VEH 1
F-DA
26 NTPL1
F-CL
IC202
NVM
8 VCC
SCL 6
SDA 5
5
BA BLOCK
7-3
VPL-CS1
A
B
C
D
7-3
E
F
G
H
B
B
B(MAIN CPU,A/D CONVERTER,CSAN CONVERTER,SDRAM,LVDS RECEIVER,RGB INPUT,SYNC SEP)
1
TP404
R
TP403
G
TP402
B
IC404
VIDEO SW
V-R
V-G
V-B
CN404
R-Y
Y
B-Y
PAL V
11 IN2(R)
13 IN2(G)
16 IN2(B)
IC409
A/D CONVERTER
R
G
B
OUT(R) 35
OUT(G) 30
OUT(B) 27
R
G
B
7 R IN
15 G IN
22 B IN
DRA0
112
DRA7
DRB0
105
R OLD0-7
102
R NEW0-7
2 IN1(R)
5 IN1(G)
7 IN1(B)
SW 19
DRB7 95
DGA0 92
INPUT-A
4 GREEN IN
V.POL 19
H.POL 18
CLAMP 17
6 C/H
8 V IN
G OLD0-7
IC406
D/A CONVERTER
IC407
G SYNC SEPA
DGA7 85
DGB0 82
1 SW1
2 SW0
11
G NEW0-7
DAC2 5
DAC3 4
10
SDA
SCL
IC401(5/6)
DGB7 75
14 SDA
15 SCL
HD 14
VD 13
DBA0 72
B OLD0-7
DBA7 65
DBB0 62
12
2
B NEW0-7
13
DBB7 55
IC401(6/6)
IC402
INV SW
V-HD
1
19
6
4
11
2
13
17
IC429
DDC
6 SCL
5 SDA
VCLK 7
15
IC401
(1/6)
15K-CS
9
3
18
7
14
5
16
IC403
2
1
IC401
(2/6)
2
3
7
5
IC403
1
2
6
4
COAST
41 COAST
TP401
VSI
IC401(4/6)
9
8
HSOUT
117
VSI
TP406
PICLK
VSI
CLAMP
28 CLAMP
TP405
HSI
IC405
MONO MULTI
1
DATACK/
DATACK
V-VD
9 2A
1 1A
V-CLP
116
115
HSI
HSI
IC403
6
IC401
(3/6)
4
2Q 12
1Q 4
40 HSYNC
IC410
BUFFER
SDA
SCL
2 1A
5 2A
1B 3
2B 6
29 SDA
30 SCL
VSI
3
IC427
MAIN CPU
HSI
3.3V-2
X401
52MHz XTAL
IC421
INV
POCLK
VDD
3.3V-2
OUT
1
3
5
13
X402
70MHz XTAL
VDD
1A
2A
3A
6A
IC424
OSD
IC423
INVERTER
1Y
2Y
3Y
6Y
2
4
6
12
POHS
MEMCLK
POVS
1
5
9
13
1A
3A
4A
6A
2Y
3Y
4Y
5Y
4
6
8
10
10 HSYNC
SRX
POVS
5 DCLK1
11 VSYNC
OUT
OSD CS
SDAT(OSD)
SCLK(OSD)
OSD ON
RESN
TRE
4
VSI
5
7
4
16
6
14
1
2
3
12
13
15
15
13
2
18
CS
SIN
SCLK
DISP
RESET
BISY
25
26
27
28
24
17
31
19
33
PB4
TCLKC
PB6
TIOCB2
116 RXD3
30 IRQ0
OSDDT3
OSDDT2
OSDDT1
OSDDT0
2
1
4
OSDEN
IC426
10
IC425
FLASH
2
6
3
7
8
4
SDAT(OSD)
SCLK(OSD)
OSD CS
RESN
OSD ON
TRE
CN406
TXD
FWR
RXD
MD1
MD2
RES
22
24
43
111
112
113
PE1
PE2
PE3
PE4
AN0/P40
AN1/P41
AN2/P42
AN3/P43
35
36
37
38
39
94
95
96
SDA-IN
SDA-OUT
SCL
SCL1
SDA1
ZOOM
PB2
PB1
PC2
TXD2(FWR)
PC1
PC0
SCLK
PD0
PB0
AN8/P90
P71
AN9/P91
P72
P73
P74
8
6
4
57
55
15
14
3
2
1
12
74 FWE
23 RXD2(FWR)
119 MD1
120 MD2
71 RES
67 WDTOVF
IC422
NVM
IC420
RESET
3.3V-1
IC418
CPU RES
2 VDD
OUT 1
5
6
3
Q403,404
RES
SW
8 VCC
SCL 6
SDA 5
2 VDD
F-CL
F-DA
F+5V
IC419
RESET
5V-1
5
PE5
PE6
PD4
PD5
PD6
PD7
RXD4
TXD4
AN4/P44
AN5/P45
DA0/AN6/P46
DA1/AN7/P47
SCK3
TXD3
101
102
PSAVE LED
LAMP LED
TEMP LED
POWER LED
KEY0
KEY1
LAMP TEMP
PANEL TEMP
SDA
SCL
U-CL
U-DA
NR OFF
NF OFF
F-DA
F-CL
SIRCS
FILTER COVER
LAMP COVER
PWR PROT
114
39
40
48
49
50
51
60
61
97
98
99
100
115
LAMP ON
POWER ON
DAC CS
AUDIO CS
AUDIO MUTE
EXT SW
RXD
TXD
LAMP SENS
FAN PROT
FAN CONT1
FAN CONT2
SCLK
SDAT
117
OUT 1
APA CS
PD3 47
SC CS
PD2 46
SC RST
P70 110
USB REQ
PD1 45
7-4
A
B
C
D
7-4
VPL-CS1
E
F
G
H
B
B
190
R AD
PID0
MD0 7
PID7
PID8
10
12
14
198
21 A0
22
23
24
27
28
29
30
31
32
20 A10/AP
199
R NEW0-7
17
20
201
203
G AD
G OLD0-7
207
PID15
208
PID16
24
27
31
34
211
214
217
218
38
41
PID23
PID24
MD0-47
14
15
16
17
18
19
36
35
B AD
G NEW0-7
45
48
223
225
PID31
227
PID32
234
PID39
PID40
235
B NEW0-7
IC408
D-FF
2 1D
12 2D
3 1CK
11 2CK
244
PID47
245
PIVS
PIHS
PICLK
246
248
PICLK
SC CS
SDAT
SC RST
SCLK 2
58
61
DQ0 2
3
5
6
8
9
11
12
39
40
42
43
45
46
48
DQ15 49
IC415
SDRAM
253
254
100
4
252
SS
SI
RST
SCLK
IC428
112
111
110
107
106
64
66
68
71
MD47 73
MA0 80
83
86
MA10
CS
DQM0
DQM1
BA0
MWR
RAS
CAS
92
2
3
4
76
77
78
79
POD0
118
OSDDT3
OSDDT2
OSDDT1
OSDDT0
OSDEN
V-B
MD0-15
MD16-31
MD32-47
PAL V
15K-CS
(SAME AS IC416)
(SAME AS IC416)
V-HD
V-VD
MA0-10
CS
LDQM
UDQM
BA
WE
RAS
CAS
22
20
127
129
28
16
131
14
12
G00-09
10
8
7
6
4
140
142
POD19
POD20
145
148
152
115
105
POD29
159
PIFLD
POFLD
250
CN401
A24
B24
SDA
A22
B22
SCL
A23
B23
F-DA
A25
B25
F-CL
A26
B26
LAMP COVER
A27
FILTER COVER
B27
U-DA
A28
NR OFF
B28
U-CL
A29
NF OFF
B29
PWR PROT
A31
SIRCS
B31
A-R
A33
B33
A-G
A34
B34
A-L
A35
B35
TATA+
TBTB+
TCTC+
TCLKTCLK+
TDTD+
2
E
TO
C BOARD
CN803
3
F+5V
2
56
B00-09
155
116
48
47
46
45
42
41
40
39
38
37
132
138
SO
POVS
POHS
POCLK
H
TO
QA BOARD
CN105
R00-09
125
135
1
1
27
25
122
POD9
POD10
SRX
POVS
POHS
POCLK
CN405
31
30
28
27
25
24
22
21
19
18
16
14
12
10
8
6
4
3
2
1
V-G
IC413
LDVS RECEIVER
OSD-SIG
TATA+
TBTB+
TCTC+
TCLKTCLK+
TDTD+
SCL
SDA
PANEL TEMP
LAMP TEMP
KEY0
KEY1
PSAVE LED
LAMP LED
TEMP LED
POWER LED
V-R
120
OSDDT3
OSDDT2
OSDDT1
OSDDT0
OSDEN
V-CLP
USB REQ
B-Y
238
PIHS
1Q 6
PIVS
2Q 9
PIVS
PIHS
PICLK
51
53
55
LDQM
WE
CAS
RAS
CS
BA
UDQA
CLK
IC414
SDRAM
MEMCLK
B OLD0-7
226
Y
IC416
SDRAM
R OLD0-7
197
CN402
A2
B2
A4
B4
A6
B6
A8
B8
A10
B10
A12
B12
A14
B14
A16
B16
A18
B18
A19
B19
A20
B20
A25
R-Y
IC417
SCAN CONVERTER
54
52
POFLD
POHS
POVS
POCLK
117
28
30
31
IC412
APA
POFLD
PIHS
PIVS
PICLK
69
65
41
1
FLDIN
HDXIN
VDX
CLK
3 DIN27
B OLD7-0
10 DIN20
11 DIN17
13
SRX
B NEW7-0
A-R
A-G
SDOUT 77
A-L
IC411
BUFFER
19 DIN10
SDAT
APA CS
SCLK
SDAT
2
5
9
12
1A
2A
3A
4A
1Y
2Y
3Y
4Y
3
6
8
11
78 SDIN
SCLK
80 SCSIN
79 SCLK
DAC CS
AUDIO CS
AUDIO MUTE
LAMP SENS
FAN PROT
FAN CONT1
FAN CONT2
LAMP ON
POWER ON
EXT SW
TXD
RXD
CN403
B25
A25
B24
A24
B23
A23
B21
A21
B19
A19
B17
A17
A16
B5
A5
B4
A4
B3
A3
B2
A2
B1
G
TO
QA BOARD
CN103
4
F
5
TO
C BOARD
CN801
B BLOCK
7-5
VPL-CS1
A
B
C
D
7-5
E
F
G
H
C, H
C, H
C(LCD DRIVE,RGB AMP,AUDIO AMP,12CH DAC,TIMING GENERATER)
1
B3
B5
A3
CN801
LAMP ON
LAMP SENS
POWER ON
CN805
L CONT OUT
1
2
L CONT IN
IC804(1/4)
5
6
10
9
8
LAMP
SCI
FLAG
IC804(3/4)
RXD
TXD
EXT SW
B1
A2
B2
F
CN806
1
3
1
3
CN807
POWER CONT
1
FAN PROT
2
FAN CONT1
3
FAN CONT2
4
FAN PROT
FAN CONT1
FAN CONT2
A5
B4
A4
TEMP
FUSE
RXD
TXD
EXT SW
CN809
2
3
5
SP-L
CN814
3
SP-R
1
BALLAST
C
TO
GBA BOARD
CN674
H(KEY INPUT,LED)
VISCA
KEY-MATRIX
TO
B BOARD
CN403
2
IC820
VOLUME
A23
B23
A25
B25
A17
A21
B21
A19
B19
A-L
A-L
A-R
A-R
AUDIO CS
SDAT
SDAT
SCLK
SCLK
B17
A16
DAC CS
AUDIO MUTE
IC821
AUDIO AMP
S001-008
A-L
20
15
6
5
3
L
KEY-MATRIX
A-R
1
APCE
SDAT
12
13
11
IC819
AUDIO AMP
APCE
7
SDAT
8
A-SCLK
9
A-SCLK
IC804(4/4)
6
7
8
CN808
KEY0
3
KEY1
4
PSAVE LED
7
LAMP LED
8
TEMP LED
9
POWER LED
10
1
Q812,813
D-SCLK
DALD
S009-012
R
MUTE
CN1001
LED
3
4
7
8
9
10
Q810,811
23
1
Q816
CN803
LAMP TEMP
LED TEMP
32
31
30
29
27
25
3
MUTE
IC803
RGB AMP
TO
B BOARD
CN405
SDA
SCL
15
14
12
11
9
8
6
5
3
2
RD+
RDRCLK+
RCLKRC+
RCRB+
RBRA+
RA-
R OUT 41
BUFF
TP804
G
Q814
G DA
G
6 GIN
G OUT 38
BUFF
TP803
B
Q815
B DA
B
11 BIN
B OUT 33
BUFF
23 SDA
22 SCL
21 CLP
IC811
PECL DRV
IC812
4
CLK
2
4
7 D
CN810
PLD
1
3
5
6
7
IC805
LVDS RECEIVER
HSO
VSO
RARA+
RBRB+
RCRC+
RCLKRCLK+
RDRD+
5
7-6
B
C
IC809
TG
MCLK
Q 2
MCLK
Q 3
HSO
VSO
IC808
INVERTER
CLP
1 I/O28
10 I/O1
I/O10 21
1
3
5
9
11
13
HCK1
I/O21 36
HCK2
I/O20 35
TP814
HD
A
M.OUT
R
2 RIN
19
17
1
2
3
4
5
TP805
R
Q801
R DA
E
D008
POWER/STBY
CN804
R
G
B
VD
HD
TH802
LCD
POWER LED
TEMP LED
LAMP LED
PSAVE LED
KEY1
KEY0
Q001
SWITCH
SWITCH
TH801
LAMP
D001-003
D
TP813
VD
5
6
9
10
11
12
15
16
17
18
19
20
CLKOUT
RC3
RD6
RC4
RA1
RC5
RA2
RC6
RA3
RA4
RD1
RA5
RARA6
RA+
RB0
RBRB1
RB+
RD2
RCRD3
RC+
RB2
RCLKRB3
RCLK+
RB4
RDRB5
RD+
RD4
RD5
RB6
RC0
RC1
RC2
26
1
2
3
29
30
32
33
34
35
37
38
39
41
42
43
45
46
47
49
50
51
53
54
55
IC806
D/A CONVERTER
24
43
42
41
23
22
21
20
19
18
17
16
10
9
8
7
6
5
4
3
48
47
46
45
44
CLOCK
R4
R3
R2
B9
B8
B7
B6
B5
B4
B3
B2
B1
G8
G7
G6
G5
G4
G3
G2
R9
R8
R7
R6
R5
27
30
7
8
18
TP815
R DA
Y2/SCLK
IN2/MODE
ISPEN
SDI/IN0
SDO/IN1
R DA
IOR 34
PB DIR
DNW
TP816
G DA
32 I/O18
33 I/O17
1A
2A
3A
4A
5A
6A
1Y
2Y
3Y
4Y
5Y
6Y
HCK1R
HCK1G
HCK1B
HCK2B
HCK2G
HCK2R
2
4
6
8
10
12
IC810
INVERTER
VCK
I/O24 41
ENB
I/O2 11
VST
I/O26 43
I/O16 31
HST
I/O19 34
PCG
I/O11 9
1
3
5
9
11
13
G DA
1A
2A
3A
4A
5A
6A
1Y
2Y
3Y
4Y
5Y
6Y
VCK
ENB
VST
PRG
HST
PCG
2
4
6
8
10
12
IC822(5/6)
IOG 32
PRG
FRP
IC822(1/6)
TP817
B DA
1
2
I/O25 42
B DA
IOB 28
IC807
REF
VREF 36
8
4
7-6
VPL-CS1
E
F
G
H
C, H
C, H
TP809
R INV
1
IC818
R LCD DRIVER
+15.5V
46 INV-OUT
VID4
VID3
VID5
VID2
VID6
VID1
R OUT
47 VIDEO IN
POS-CON1
POS-CON2
SCEN
SID-OUT
DLY-CON
INV-CON
ENB
FRP
PRG
1
2
35
39
49
52
POS-CNT1
POS-CNT2
SIG CEN
SID-IN
DLY-CNT
INV-CNT
SH-OUT4
SH-OUT3
SH-OUT5
SH-OUT2
SH-OUT6
SH-OUT1
21
27
19
29
17
31
DIR-CNT 13
VCOM OUT 33
12 ENB
44 FRP
62 PRG
Q806,807
R-SID IN
SID-OUT 38
MCLK
MCLK
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
R-SID
BUFF
R-SID OUT
50 MCLK
51 MCLK
R VCOM
CN813
8
23
2
3
4
5
6
7
RGT
COM
HST
HCK2R
HCK1R
ENB
VCK
VST
PCG
PSIG
9
24
13
14
15
18
19
20
21
1
DWN
22
LCD PANEL
(R)
34 VCOM OFST
DWN
2
TP806
G INV
IC815
G LCD DRIVER
+15.5V
G OUT
VID4
VID3
VID5
VID2
VID6
VID1
POS-CON1
POS-CON2
SCEN
SID-OUT
DLY-CON
INV-CON
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
(SAME AS R PROCESS)
ENB
FRP
PRG
Q804,805
G-SID IN
MCLK
MCLK
G-SID
BUFF
G-SID OUT
G VCOM
DWN
CN811
8
23
2
3
4
5
6
7
RGT
COM
HST
HCK2G
HCK1G
ENB
VCK
VST
PCG
PSIG
9
24
13
14
15
18
19
20
21
1
DWN
22
LCD PANEL
(G)
3
TP810
B INV
IC817
B LCD DRIVER
+15.5V
B OUT
IC813
12CH D/A CONVERTER
Q802
A03 2
BUFF
VID4
VID3
VID5
VID2
VID6
VID1
POS-CON1
POS-CON2
SCEN
SID-OUT
DLY-CON
INV-CON
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
B VCOM
RGT
COM
HST
HCK2B
HCK1B
ENB
VCK
VST
PCG
PSIG
9
24
13
14
15
18
19
20
21
1
DWN
DWN
22
(SAME AS R PROCESS)
SID-OUT
ENB
FRP
PRG
IC814
SWITCH
Q808,809
1
Q803
PRG
B-SID IN
15
A04 3
SDAT
D-SCLK
DALD
17 DI
16 CLK
15 LD
A08 7
A09 8
A010 9
A011
A012
SH2
A06
SCEN
A05
12
13
19
5
18
4
BUFF
2
R VCON
G VCON
B VCON
CN812
8
23
2
3
4
5
6
7
MCLK
MCLK
POS-CON1
POS-CON2
SCEN
DWN
DLY-CON
INV-CON
B-SID
BUFF
B-SID OUT
LCD PANEL
(B)
4
IC801
+15V REG
+16.5V
I
O
+15.5V
IC802
+12V REG
IC822(2/6)
4
I
O
+12V
3
A07 6
PB DIR
5
C, H BLOCK
7-7
VPL-CS1
A
B
C
D
7-7
E
F
G
H
GA, GBA, GBB
GA, GBA, GBB
1
GA
POWER SUPPLY,DC-DC CONVERTER,
POWER-FACTOR REGULATING CONTROL
CN601
3
AC
INLET
1
GBA(FAN
L601
LFT
AC(N)
1
AC(L)
4
CN674
CN671
D601
RECT
2
DRIVE,DC-DC CONVERTER)
D602
RECT
CN607
1
2
3
4
5
6
1
DC W
3
IC605
POWER-FACTOR
REGULATING CONTROL
CN602
Q601
GND
SWITCHING
2
3 VDET
16 IDET
D610
RECT
10 VCC
9 VC
OUT
VFB
VIN
OVP
1
8
5
6
4
IC673
DC-DC CONVERTER
3 FB
VSW 8
1 VIN
BST 2
D673
RECT
CN608
CN676
1
GND 1 B
IC704
REG
ADJ
I
O
G
POWER CONT
1
FAN PROT
FAN CONT1
FAN CONT2
GND2
2
3
4
5
C
TO C BOARD
CN807
FAN 1
1
2
3
Q604
INV
POWER CONT
GND2
FAN PROT
GND2
18V
GND2
FAN +B
FAN PROT
GND2
12 ON/OFF
D672
Q672,673
FAN PROT
SW
T601
SRT
D607
NOIS
FILTER
CN675
IC672
+5V REG
D609
RECT
7
D608
NOIS
FILTER
I
1
O
G
6
3
5
FAN 2
CN605
1
2
3
4
SUB+5V
SUB+5V
GND2
GND2
1
2
3
FAN +B
FAN PROT
GND2
A
TO QA BOARD
CN101
9
2
8
4
3
PH601
ISOLATER
IC603
PWM CONTROL
D
C
CN604
4
1
3
2
1 K
S
POWER
ON
T602
SRT
2
C
REF 8
A 7
PH602
ISOLATER
Q603
D
4
1
3
2
3
11
IC604
PWM CONTROL
5
10
6
9
D615,617
+6V RECT
PH603
ISOLATER
4
1
3
2
4
GBB(+16.5V
IC671
SHUNT REG
1 K
REF 8
A 7
Q671
REG,AUDIO +B REG)
D728
RECT
CN606
T-OUT12
T-OUT12
T-OUT11
6V
6V
GND2
GND2
GND2
GND2
18V
12
D621
RECT
S
1
2
3
4
5
6
POWER CONT
GND2
FAN PROT
GND2
18V
GND2
IC602
SHUNT REG
CN702
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
T-OUT12
T-OUT12
T-OUT11
6V
6V
GND2
GND2
GND2
GND2
18V
D715
RECT
Q710
AUDIO
AMP
IC701
+16.5V REG
I
O
G
CN706
AUDIO+B
AUDIO+B
AUDIO GND
AUDIO GND
+16.5V
+16.5V
GND2
GND2
1
2
3
4
5
6
7
8
D
TO C BOARD
CN802
CN707
+16.5V
AUDIO+B
GND2
GND2
+6V
+6V
GND2
GND2
GND2
SW
1
2
3
4
5
6
7
8
9
B
TO QA BOARD
CN102
5
GA, GBA, GBB BLOCK
7-8
A
B
C
D
7-8
VPL-CS1
E
F
G
H
A
B
C
VPL-CS1
D
8-1
E
CN601
3P
:VH-B
F
SUB 5V
SUB 5V
GND
GND
BALAST
16.5V
AUDIO+B
GND 2
GND 2
+6V
+6V
GND 2
GND 2
GND 2
1
2
3
4
5
6
7
8
9
CN676
3P
BLK
:S-MICRO
1
2
3
4
GBA
T-OUT12
T-OUT12
T-OUT11
6V
6V
GND 2
GND 2
GND 2
GND 2
18V
CN675
3P
WHT
:S-MICRO
1
2
3
4
5
6
7
8
9
10
H
1
2
3
4
5
6
7
8
AUDIO+B
AUDIO+B
AUDIO GND
AUDIO GND
+16.5V
+16.5V
GND 2
GND 2
AUDIO +B
AUDIO +B
AUDIO GND
AUDIO GND
+16.5V
+16.5V
GND
GND
L CONT OUT
L CONT IN
1
2
3
4
5
6
7
8
1
2
CN802
8P
WHT
:SMD
PLD
M.OUT
(G)
CN671
8P
WHT
CN604 CN606
8P
10P
LAMP
AC IN
100V-120V
220V-240V
50/60Hz
G
CN7106
8P
WHT
:S-MICRO
CN7102
10P
SP-R
AUDIO GND
SP-L
AUDIO GND
POWER CONT
FAN PROT
FAN CONT1
FAN CONT2
GND 2
1
2
3
4
5
CN807
4P
WHT
:SMD
1
2
3
4
5V
VD
HD
GND
B
GND
G
GND
R
9
8
7
6
5
4
3
2
1
CN804
9P
WHT
:SMD
1
2
3
4
5
6
7
8
9
10
SCLK
GND
MODE
PLUG
ISPEN
SDI
SDO
VCC
1
2
3
4
5
6
7
8
CN803
32P
WHT
T-OUT12
T-OUT12
T-OUT11
6V
6V
GND 2
GND 2
GND 2
GND 2
18V
CN001
12P
:SMD
1
2
3
4
5
FAN2
POWER CONT
FAN PROT
FAN CONT1
FAN CONT2
GND 2
LCD
PANEL
CN810
8P
WHT
:SMD
AC(N)
N.C
AC(L)
TO AC INLET
(R)
CN806
3P
WHT
:SMD
POWER CONT
GND 2
FAN PROT
GND 2
18V
GND 2
SCI
GND
FLAG
1
2
3
CN813
24P
WHT
CN808
12P
WHT
:SMD
1
2
3
4
5
6
POWER LED
D 5V
GND
CN812
24P
WHT
TO FAN1
1
FAN+B
2
FAN PROT
3
GND 2
GND
N.C
KEY0
KEY1
SUB 5V
N.C.
PSAVE LED
LAMP LED
TEMP LED
1
2
3
4
5
6
7
8
9
10
11
12
CN809
5P
WHT
:SMD
TO FAN2
1
FAN+B
2
FAN PROT
3
GND 2
PSIG
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
HVDD
RGT
MODE3
MODE2
MODE1
HST
HCK1
HCK2
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN811
24P
WHT
3
2
1
1
2
3
4
5
6
1
2
3
1
2
3
4
5
6
7
8
9
10
11
12
LCD
PANEL
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
1
2
3
4
5
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
B25
A25
B24
A24
B23
A23
B22
A22
B21
A21
B20
A20
B19
A19
B18
A18
B17
A17
B16
A16
B15
A15
B14
A14
B13
A13
B12
A12
B11
A11
B10
A10
B9
A9
B8
A8
B7
A7
B6
A6
B5
A5
B4
A4
B3
A3
B2
A2
B1
A1
SIG5
SIG2
SIG6
SIG1
HVDD
XRGT
MODE3
MODE2
MODE1
HST
HCK2
HCK1
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
SUB 5V
RXD
TXD
GND
EXT SW
POWER LED
TEMP LED
LAMP LED
PSAVE LED
GND
KEY1
GND
KEY0
GND
LAMP TEMP
GND
LCD TEMP
GND
SDA
GND
SCL
GND
RD+
RDGND
RCLK+
RCLKGND
RC+
RCGND
RB+
RBGND
RA+
RAGND
GND
RXD
TXD
EXT SW
FAN ON
LAMP ON
POWER ON
FAN CONT1
FAN PROT
LAMP SENS
GND
GND
D+5V
D+5V
GND
GND
SUB+5V
SUB+5V
GND
GND
D+3.3V
D+3.3V
GND
GND
A+5V
A+5V
A+5V
A+5V
GND
GND
AUDIO MUTE
GND
AUDIO CS
DAC CS
GND
GND
SCLK
SCLK
GND
GND
SDAT
SDAT
GND
GND
A-L
A-L
A-G
A-G
A-R
A-R
PSIG
SIG4
SIG3
FRAME (1/2)
POWER CONT
GND 2
FAN PROT
GND 2
18V
GND 2
SCI
GND
FLAG
GND
SIRCS NR
KEY0
KEY1
SUB 5V
LIGHT
PSAVE-LED
LANP-LED
TEMP-LED
POWER-LED
D.5V
GND
PSIG
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
HVDD
RGT
MODE3
MODE2
MODE1
HST
HCK1
HCK2
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
Section 8
Diagrams
FRAME (1/2)
8-1. Frame Schematic Diagram
(B)
LCD
PANEL
1
VISCA
TO B BOARD CN405
TO B BOARD CN403
CN801
50P
WHT
C
CN805
2P
RED
:SMD
CN814
4P
RED
:SMD
2
SPEAKER
TEMP
FUSE
FAN1
3
GBB
CN674
4P
WHT
:S-MICRO
CN7107
9P
RED
:S-MICRO
4
TO QA BOARD CN102
GA
CN672
4P
5
TO QA BOARD CN101
B-SS1697<08.>-KESSEN-P2
8-1
H
A
B
3
2
1
TO GBB BOARD CN7107
TO GA BOARD CN674
4
V-B
V-B
GND
GND
V-G
V-G
GND
GND
V-R
V-R
GND
GND
Y
Y
GND
GND
R-Y
R-Y
GND
GND
B-Y
B-Y
GND
GND
VIDEO
VIDEO
GND
GND
Y
Y
GND
GND
C
C
GND
GND
PAL-V
PAL-V
15K-CS
15K-CS
S-IN
S-IN
V-CLP
V-CLP
V-HD
V-HD
V-VD
V-VD
SCL
SCL
SDA
SDA
F+5V
F+5V
F-CL
F-CL
F-DA
F-DA
GND
GND
A5V
A5V
A5V
A5V
GND
GND
+9V
+9V
+9V
+9V
CN071
3P
RED
:SMD
B35 B35
A35 A35
B34 B34
A34 A34
B33 B33
A33 A33
B32 B32
A32 A32
B31 B31
A31 A31
B30 B30
A30 A30
B29 B29
A29 A29
B28 B28
A28 A28
B27 B27
A27 A27
B26 B26
A26 A26
B25 B25
A25 A25
B24 B24
A24 A24
B23 B23
A23 A23
B22 B22
A22 A22
B21 B21
A21 A21
B20 B20
A20 A20
B19 B19
A19 A19
B18 B18
A18 A18
B17 B17
A17 A17
B16 B16
A16 A16
B15 B15
A15 A15
B14 B14
A14 A14
B13 B13
A13 A13
B12 B12
A12 A12
B11 B11
A11 A11
B10 B10
A10 A10
B9 B9
A9 A9
B8 B8
A8 A8
B7 B7
A7 A7
B6 B6
A6 A6
B5 B5
A5 A5
B4 B4
A4 A4
B3 B3
A3 A3
B2 B2
A2 A2
B1 B1
A1 A1
3
2
1
GND
GND
SUB 5V
SUB 5V
GND
SIRCS-NF
SUB+5V
CN101
4P
GND
SIRCS-NF
SUB+5V
GND
GND
GND
+6V
+6V
GND
GND
AUDIO+B
+16.5V
CN102
9P
4
3
2
1
9
8
7
6
5
4
3
2
1
CN123
3P
:SMD
V-B
V-B
GND
GND
V-G
V-G
GND
GND
V-R
V-R
GND
GND
Y
Y
GND
GND
R-Y
R-Y
GND
GND
B-Y
B-Y
GND
GND
VIDEO
VIDEO
GND
GND
Y
Y
GND
GND
C
C
GND
GND
PAL-V
PAL-V
15K-CS
15K-CS
S-IN
S-IN
V-CLP
V-CLP
V-HD
V-HD
V-VD
V-VD
SCL
SCL
SDA
SDA
F+5V
F+5V
F-CL
F-CL
F-DA
F-DA
GND
GND
A5V
A5V
A5V
A5V
GND
GND
+9V
+9V
+9V
+9V
B25 B25
A25 A25
B24 B24
A24 A24
B23 B23
A23 A23
B22 B22
A22 A22
B21 B21
A21 A21
B20 B20
A20 A20
B19 B19
A19 A19
B18 B18
A18 A18
B17 B17
A17 A17
B16 B16
A16 A16
B15 B15
A15 A15
B14 B14
A14 A14
B13 B13
A13 A13
B12 B12
A12 A12
B11 B11
A11 A11
B10 B10
A10 A10
B9 B9
A9 A9
B8 B8
A8 A8
B7 B7
A7 A7
B6 B6
A6 A6
B5 B5
A5 A5
B4 B4
A4 A4
B3 B3
A3 A3
B2 B2
A2 A2
B1 B1
A1 A1
B35 B35
A35 A35
B34 B34
A34 A34
B33 B33
A33 A33
B32 B32
A32 A32
B31 B31
A31 A31
B30 B30
A30 A30
B29 B29
A29 A29
B28 B28
A28 A28
B27 B27
A27 A27
B26 B26
A26 A26
B25 B25
A25 A25
B24 B24
A24 A24
B23 B23
A23 A23
B22 B22
A22 A22
B21 B21
A21 A21
B20 B20
A20 A20
B19 B19
A19 A19
B18 B18
A18 A18
B17 B17
A17 A17
B16 B16
A16 A16
B15 B15
A15 A15
B14 B14
A14 A14
B13 B13
A13 A13
B12 B12
A12 A12
B11 B11
A11 A11
B10 B10
A10 A10
B9 B9
A9 A9
B8 B8
A8 A8
B7 B7
A7 A7
B6 B6
A6 A6
B5 B5
A5 A5
B4 B4
A4 A4
B3 B3
A3 A3
B2 B2
A2 A2
B1 B1
A1 A1
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
V-CLP
V-CLP
V-VD
V-VD
V-HD
V-HD
GND
GND
15-CS
15-CS
GND
GND
PALV
PALV
GND
GND
V-B
V-B
GND
GND
V-G
V-G
GND
GND
V-R
V-R
GND
GND
B-Y
B-Y
GND
GND
Y
Y
GND
GND
R-Y
R-Y
GND
GND
A-L
A-L
A-G
A-G
A-R
A-R
GND
GND
SIRES
SIRES
GND
GND
NF OFF
U-CL
NR OFF
U-DA
FAN-C
LAMPC
F-CL
F-CL
F-DA
F-DA
F+5V
F+5V
SCL
SCL
SDA
SDA
GND
GND
SUB+3V
SUB+3V
SUB+3V
SUB+3V
GND
GND
GND
GND
SUB+5V
SUB+5V
SUB+5V
SUB+5V
GND
GND
GND
GND
D+3.3V
D+3.3V
D+3.3V
D+3.3V
GND
GND
GND
GND
D+5V
D+5V
D+5V
D+5V
GND
GND
A+3.3V
A+3.3V
GND
GND
GND
GND
A+5V
A+5V
A+5V
A+5V
8-2
C
D
A-L
A-L
A-G
A-G
A-R
A-R
GND
GND
SIRES
SIRES
GND
GND
NF OFF
U-CL
NR OFF
U-DA
FILC
LAMPC
F-CL
F-CL
F-DA
F-DA
F+5V
F+5V
SCL
SCL
SDA
SDA
GND
GND
SUB+3V
SUB+3V
SUB+3V
SUB+3V
GND
GND
GND
GND
SUB+5V
SUB+5V
SUB+5V
SUB+5V
GND
GND
GND
GND
D+3.3V
D+3.3V
D+3.3V
D+3.3V
GND
GND
GND
GND
D+5V
D+5V
D+5V
D+5V
GND
GND
A+3.3V
A+3.3V
GND
GND
GND
GND
A+5V
A+5V
A+5V
A+5V
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
V-CLP
V-CLP
V-VD
V-VD
V-HD
V-HD
GND
GND
15-CS
15-CS
GND
GND
PALV
PALV
GND
GND
V-B
V-B
GND
GND
V-G
V-G
GND
GND
V-R
V-R
GND
GND
B-Y
B-Y
GND
GND
Y
Y
GND
GND
R-Y
R-Y
GND
GND
CN405
32P
WHT
CN402
50P
B
CN105
50P
3
E
8
7
6
5
4
3
2
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
POWER LED
TEMP LED
LAMP LED
PSAVE LED
GND
KEY1
GND
KEY0
GND
LAMP TEMP
GND
PANEL TEMP
GND
SDA
GND
SCL
GND
TD+
TDGND
TCLK+
TCLKGND
TC+
TCGND
TB+
TBGND
TA+
TAGND
CN403
50P
MD2
MD1
FWR
VIN
RES
RXD
TXD
GND
B25
A25
B24
A24
B23
A23
B22
A22
B21
A21
B20
A20
B19
A19
B18
A18
B17
A17
B16
A16
B15
A15
B14
A14
B13
A13
B12
A12
B11
A11
B10
A10
B9
A9
B8
A8
B7
A7
B6
A6
B5
A5
B4
A4
B3
A3
B2
A2
B1
A1
GND
RXD
TXD
EXT SW
FAN ON
LAMP ON
POWER ON
FAN CONT1
FAN PROT
LAMP SENS
GND
GND
D+5V
D+5V
GND
GND
SUB+5V
SUB+5V
GND
GND
D+3.3V
D+3.3V
GND
GND
A+5V
A+5V
A+5V
A+5V
GND
GND
AUDIO MUTE
GND
AUDIO CS
DAC CS
GND
GND
SCLK
SCLK
GND
GND
SDAT
SDAT
GND
GND
A-L
A-L
A-G
A-G
A-R
A-R
FRAME (2/2)
FRAME (2/2)
1
TO C BOARD CN801
TO C BOARD CN803
FLASH
F
CN406
8P
WHT
:SMD
CN401
70P
2
CN103
70P
QA
CN104
70P
CN201
70P
NF
BA
B-SS1697<08.>-KESSEN-P1
5
8-2
VPL-CS1
G
H
8-2. Schematic Diagrams and
Printed Wiring Boards
Note:
• Parts marked “ * ” differ according to the model/destination. Refer
to the mount table for each function.
• The parts marked “ # ” on schematic diagrams are not mounted.
• All capacitors are in µF unless otherwise noted. pF: µµF 50WV or
less are not indicated except for electrolytics.
• All electrolytics are in 50 V unless otherwise specified.
•
: fusible resistor
•
: nonflammable resistor
•
: panel designation and adjustment for repair
• Caution when replacing chip parts
New parts must be attached after removal of the chip.
Be careful not to heat the minus side of a tantalum capacitor,
because it is easily damaged by the heat.
Reference information
RESISTOR
RN
RC
FPRD
FUSE
RS
RB
RW
: METAL FILM
: SOLID
: NONFLAMMABLE CARBON
: NONFLAMMABLE FUSIBLE
: NONFLAMMABLE METAL OXIDE
: NONFLAMMABLE CEMENT
: NONFLAMMABLE WIREWOUND
: ADJUSTMENT RESISTOR
COIL
LF-8L
: MICRO INDUCTOR
CAPACITOR
TA
PS
PP
PT
MPS
MPP
ALB
ALT
ALR
: TANTALUM
: STYROL
: POLYPROPYLENE
: MYLAR
: METALIZED POLYESTER
: METALIZED POLYPROPYLENE
: BIPOLAR
: HIGH TEMPERATURE
: HIGH RIPPLE
[Measuring conditions, voltage and waveform]
• A voltage value is the reference value between the measurement
point and the earth, when the NTSC color bar signal is received
from the color bar generator (digital multi-meter used: 10 M ohms/
V DC).
• A voltage value is the reference value between the measurement
point and the earth, when the NTSC color bar signal and RGB
color bar signal are received from the color bar generator (digital
multi-meter used: 10 M ohms/V DC).
• Unit of voltage is V (volt).
•
: B+line
: B– line
• Voltage variations may occur due to normal production tolerances.
• No mark : NTSC (3.58 MHz) color bar signal.
• [
] : RGB color bar signal is received.
•
: Measurement disabled.
• Circled numbers indicate the reference waveform.
•
: Signal path.
1
2
The components identified marked ! are
critical for safety.
Replace only with the part number specified.
Les composants identifiés par la marque !
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
3
4
5
8-3
VPL-CS1
A
B
C
D
8-3
E
F
G
H
NF, QA
1
2
3
F
——
QA
——
1-675-792-11
E-2
E-2
F-3
F-3
C-7
C-7
C-6
C-6
D-5
∗ D-4
∗ D-4
∗ D-3
∗ F-5
∗ F-5
∗ F-5
∗ E-5
∗ E-5
∗ F-6
∗ F-6
∗ F-6
∗ D-2
∗ D-3
1
IC101
IC102
IC103
IC104
IC105
IC105
IC107
IC108
IC121
IC121
IC122
IC123
IC124
IC125
IC127
IC128
E-4
E-4
D-3
E-3
D-4
E-6
D-5
D-5
E-7
∗ F-7
E-3
E-2
∗ E-1
E-1
C-1
D-1
3
Q102
Q103
Q104
Q105
Q106
Q107
∗ E-2
∗ E-2
∗ F-3
∗ E-1
∗ D-2
∗ D-2
C-1
C-1
X101
X102
X103
E-4
D-1
E-1
*:B Side mount
D
C
A
A
B
C
B
E
D
F
1
D101
D102
D103
D104
D105
D106
D107
D108
D109
D121
D122
D123
D124
D125
D126
D127
D128
D129
D130
D131
D133
D135
TP101
TP102
E
NF, QA
2
2
3
4
4
5
5
6
6
4
7
7
QA – B SIDE –
QA – A SIDE –
SUFFIX ; -11
SUFFIX ; -11
5
8-4
A
B
C
D
NF – B SIDE –
NF – A SIDE –
SUFFIX ; -11
SUFFIX ; -11
8-4
VPL-CS1
E
F
G
H
NF, QA (1/2)
NF, QA (1/2)
• Refer to page 8-4 for Printed Wiring Board
1
CN103
70P
CN104
70P
TO BA BOARD CN201
+9V
+9V
+9V
+9V
GND
GND
A5V
A5V
A5V
A5V
GND
GND
F-DA
F-DA
F-CL
F-CL
R101
100
:CHIP
S SEL
Y
C
4
C101
10
16V
:AL-CP
L102
BLm21B03
JL101
#
D101
RD5.6SB-T1
PROTECT
R102
75
:RN-CP
JL102
#
Q102
2SC2712
R111
22k
:CHIP
S-C
R108
1k
:CHIP
3
2
L104
BLm21B03
1
R103
75
S
:RN-CP
D103
RD5.6SB-T1
PROTECT
CN106
4P
D102
RD5.6SB-T1
PROTECT
R104
75
:RN-CP
L105
BLm21B03
J101
C103
47
16V
:AL-CP
R115
22k
:CHIP
R116
22k
:CHIP
D104
RD5.6SB-T1
PROTECT
S-Y
C120
1
10V
B:CHIP VIDEO
AUDIO IN
R160
100
:CHIP
Q104
2SC2712
C-V
F+5V
F+5V
SDA
SDA
R110
1k
:CHIP
A-L
J102
TO (1/2)
R109
1k
:CHIP
L
R105
470k
:CHIP
L106
BLm21B03
JL104
#
Q103 R159
100
2SC2712 :CHIP
+5V
JL115
#
VIDEO
R113
22k
:CHIP
R114
22k
:CHIP
Y
C102
47
16V
:AL-CP
R158
100
:CHIP
Y
R112
22k
:CHIP
D105
RD9.1SB2-T1
PROTECT
C104
10 20V :TA-CP
L109
4.7µH
R
SCL
SCL
V-VD
V-VD
V-HD
V-HD
TO (1/2)
A-R
R106
L107
BLm21B03 470k
:CHIP
JL105
#
C105
10
20V
:TA-CP
D106
RD9.1SB2-T1
PROTECT
A-GND
R107
0
:CHIP
L103
BLm21B03
SUB
SUB +3.3V
3.3V
5V
I
D +3.3V
3.3V-2
C117
47
6.3V
:AL-CP
2
L108
10µH
D108
D1FS4A-TA
JL113
#
+6V
C114
0.0033
B:CHIP
8
7
6
5
1
+5V
R164
33k
:CHIP
VIDEO
VIDEO
GND
GND
+6V
R136
10k
:CHIP
D109
1SS355
R163
100k
:CHIP
C136
10
10V
F:CHIP
R146
10k
:CHIP
R162
100k
:CHIP
+16.5V
C119
C123
C118
100
22
22
10V
10V
10V
F:CHIP F:CHIP :TA-CP
8
O
G
C116
22
16V
:AL-CP
JL112
#
BOOST
Vc
VIN FB/SNS
GND
VSW
SHDN SYNC
7
I
IC106 5V-2 D +5V NFM41P11C204
PQ05AZ1U
5V REG
EMI
3
EMI
JL114
#
1
FL103
FL105
NFM41P11C204
R100
4.7k
:RN-CP
2
JL110
C115
IC105
#
0.1 LT1376IS#TR
25V
D107 B:CHIP 3.3V DDC
D1FS4A-TA
6
C113
82
6.3V
:AL-CP
IC107
TA75W393FU
PROFECTOR
R161
1k
:CHIP
5
JL109
#
JL111
#
O
G
R147
4.7k
:CHIP
3
I
C112
22
16V
:AL-CP
R135
10k
:CHIP
R118
1.8k
:RN-CP
FB138
0
4
EMI
1
2
3
4
5
6
7
8
9
A +5V
5V-3
IC104
PQ05AZ1U
5V REG
1
C111
47
16V
:AL-CP
FL104
NFM41P11C204
C
C
GND
GND
Y
Y
GND
GND
SUB 5V
JL108
#
O
G
2
I
6V
TO GBB BOARD CN707
+16.5V
AUDIO +B
GND
GND
+6V
+6V
GND
GND
GND
C108
47
6.3V
:AL-CP
C107
22
16V
:AL-CP
IC103
TA78M09F(TE16L) 9V A +9V
9V REG
C110
33
25V
:AL-CP
CN102
9P
G
C109
47
6.3V
:AL-CP
3
EMI
O
4
FL102
NFM41P11C204
I
8
16.5V
O
G
C106
22
16V
:AL-CP
JL106
#
JL107
#
15K-CS
15K-CS
PAL-V
PAL-V
GND
GND
JL116
#
7
EMI
1
2
3
4
IC102
BA033FP-E2
3.3V REG
B-Y
B-Y
GND
GND
R-Y
R-Y
GND
GND
6
FL101
NFM41P11C204
5V-3
4
TO GA BOARD CN605
SUB +5V
SUB +5V
GND
GND
IC101
BA033FP-E2
3.3V REG
5
CN101
4P
V-CLP
V-CLP
S-IN
S-IN
A +3.3V
3.3V-3
SUB
R167
27k
:CHIP
IC108
TA75W393FU
PROFECTOR
R165
47k
:CHIP
AUDIO +B
R166
56k
:CHIP
Y
Y
GND
GND
+6V
+5V/DTR
1
IRIN1
IREN1
NF ON
IRIN2
IREN2
NR ON
RES
IROUT
VSS
C169
0.1
25V
B:CHIP
B-SS1697<08.>-NF.
+5V
IC121
GP1U28Y
VCC
OUT
GND
C121
0.1
25V
B:CHIP
R138
47k
:CHIP
JL121 #
R117
5.6k
:CHIP
C146
0.1
25V
B:CHIP
TO (1/2)
MOUSE
SIRCS
R139
100
:CHIP
CN122
6P
BUS
JL128
#
FB129
BK2125HM601
R130
47
D127
RD5.6SB-T1 :CHIP
CLK
R140
100
:CHIP
5
6
7
R123
5.6k
:CHIP
4
3
VDD
R143
10k
:CHIP
8
C133
100p
CH:CHIP
C135
1
10V
B:CHIP
8
IC123
PIC12C509 REMOTE SW
7
R072
100
1/10W
:CHIP
R122
5.6k
:CHIP
R121
5.6k
:CHIP
R137
100
:CHIP
JL118
#
6
1
2
3
5V
FROM (2/2)
DS2+
IC122
RCV4-A1S-OTP
RCV4
R120
56k
:CHIP
FB121
BK2125HM601
2
R141
47k
:CHIP
5
TO NF CN071
SUB+5V
SIRCS-NF
GND
1
C071
10
20V
:TA-CP
TO QA BOARD CN123
SUB+5V
SIRCS-NF
GND
2
1
2
3
IC071
RS-140-T
IR-RX
CN123
3P
:SMD
3
CN071
3P
WHT
:SMD
R071
47
1/10W
:CHIP
4
VCC
OUT
GND
JL122
#
17 16 15 14 13 12 11 10 9
SIRCS RECEIVE
(FRONT)
C165
33p
CH:CHIP
R119 R127
75
1M
:RN-CP :CHIP
C166
0.1
25V
B:CHIP
DS2-
D123
RB501V
VDD
X2
VDDA
USBVCC
X1
USBVSS
USB+
PC2
VSSA
PC1
PA0
PC0
PA1
RESET
N.C.
N.C.
N.C.
PB7
N.C.
PB6
PA2
VPP
PA3
PA4
PB5
PA5
PB4
PA6
PB3
PA7
PB2
PB0
PB1
C122
100
16V
:AL-CP
V-R
V-R
GND
GND
V-G
V-G
GND
GND
V-B
V-B
D121
RB501V
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34
NF
R198
1.5k
:CHIP
C164
33p
CH:CHIP
X101
24MHz
D135
RB501V
9V
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A27
B27
A28
B28
A29
B29
A30
B30
A31
B31
A32
B32
A33
B33
A34
B34
A35
B35
5V-3
L101
BLm41P750S
5V-3
L131
0
:CHIP
3.3V-3
5V-2
F-DA
F-CL
F+5V
SDA
3.3V-2
SCL
V-VD
CN105
50P
V-HD
TO B BOARD CN402
V-CLP
JL131
#
S SEL
TO (1/2)
R-Y
C130
47
6.3V
:AL-CP
15K-CS
PAL-V
C131
47
6.3V
:AL-CP
C
S-C
TO (1/2)
Y
S-Y
TO (1/2)
VIDEO
C-V
TO (1/2)
B-Y
JL132
#
Y
JL133
#
B-Y
C132
47
6.3V
:AL-CP
V-R
C128
47
6.3V
:AL-CP
V-G
C129
47
6.3V
:AL-CP
V-B
C134
47
6.3V
:AL-CP
R-Y
Y
R V-R
PAL-V
15K-CS
V-HD
V-VD
G V-G
V-CLP
B V-B
JL144
#
TO (2/2) USB REG
D122
RD5.6SB-T1
PPOTECT
R199
10k
:CHIP
USB5V TO (2/2)
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
GND
SUB
GND
R-Y
R-Y
GND
GND
Y
Y
GND
GND
B-Y
B-Y
GND
GND
V-R
V-R
GND
GND
5V
SUB
3.3V
SDA
SCL
V-G
V-G
GND
GND
V-B
V-B
GND
GND
PALV
PALV
GND
GND
15-CS
15-CS
GND
GND
V-HD
V-HD
V-VD
V-VD
V-CLP
V-CLP
GND
GND
GND
GND
GND
GND
GND
GND
USB REG
GND
F+5V
F-DA
FILTER
COVER
LAMP
COVER
S202
S101
F-CL
JL140 #
JL134 #
TO
TO
TO
TO
(2/2)
U-DA
(1/2) NR ON
(2/2)
U-CL
(1/2) NF ON
JL135 #
JL141 #
JL142 #
JL103
#
JL137
#
A-R
TO (1/2)
A-GND
A-L
JL143 #
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A27
B27
A28
B28
A29
B29
A30
B30
A31
B31
A32
B32
A33
B33
A34
B34
A35
B35
TO B BOARD CN401
A+5V
A+5V
A+5V
A+5V
GND
GND
GND
GND
A+3.3V
A+3.3V
GND
GND
D+5V
D+5V
D+5V
D+5V
GND
GND
GND
GND
D+3.3V
D+3.3V
D+3.3V
D+3.3V
GND
GND
GND
GND
SUB+5V
SUB+5V
SUB+5V
SUB+5V
GND
GND
GND
GND
SUB+3V
SUB+3V
SUB+3V
SUB+3V
GND
GND
SDA
SDA
SCL
SCL
LAMPC
FAN-C
U-DA
NR ON
U-CL
NF ON
GND
GND
PWR PROT
SIRES
GND
GND
A-R
A-R
A-G
A-G
A-L
A-L
JL129
#
FB130
BK2125HM601
C125
100p
D128
RD5.6SB-T1 CH:CHIP
5
R128
100
:CHIP
C127
0.1
25V
B:CHIP
C126
100p
CH:CHIP
QA(1/2)
R133 R134
56k
56k
:CHIP :CHIP
(VIDEO INPUT,MOUSE CONNECTOR)
B-SS1697<08.>-QA.-P1
8-5
VPL-CS1
A
B
C
D
8-5
E
4
TO (1/2) SIRCS
DAT/RI
G
FB137
0
:CHIP
3
F+5V
F+5V
F-DA
F-DA
F-CL
F-CL
R131
47
:CHIP
C137
100p
CH:CHIP
2
F
G
H
QA (2/2)
QA (2/2)
• Refer to page 8-4 for Printed Wiring Board
1
3.3V -1
X1
D10
CLK/X2
D11
AVDD1
AGND2
AGND1
OSL
8
7
1
5
6
7
R188
#
C152 R184 3k :CHIP
0.1
25V
B:CHIP
C151
0.1
C150
25V
10p
B:CHIP CH:CHIP
X102
4MHz
C148
0.1
25V
B:CHIP
DGND
D51
D50
D41
D40
DGND
DGND
D31
D30
D21
R197
10k
:CHIP
R144
C158
100
0.01
:CHIP B:CHIP
R185 3k :CHIP
R193
1.5k
:CHIP
DS3DS3+
R157
100
:CHIP
U-DA
TO (1/2)
U-CL
R156
100
:CHIP
C149
10p
CH:CHIP
5V
R154 R155
10k
33k
:CHIP :CHIP
D131
DAN202K
IC124
S-80842ANNP
RESET
RESET
2
R178 R179 R180 R181
15
15
15
15
:CHIP :CHIP :CHIP :CHIP
R148 15k :CHIP
3
USB REG
TO (1/2)
12
13
14
R177 15 :CHIP
15
16
17
18
19
20
21
22
R176 15 :CHIP
RESET
R175 15 :CHIP
R174 15 :CHIP
D20
DGND
R186 R187
100k 100k
:CHIP :CHIP
C153
0.1
25V
B:CHIP
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34
UD1
AVDD2
C160
33p
CH:CHIP
VDD
VDDA
OSCOUT USBVCC
OSCIN USBDM
VSS
USBDP
PC2
VSSA
PC1
PA0
PC0
PA1
RESET
N.C.
N.C.
N.C.
PB7
N.C.
PB6
PA2
VPP
PA3
PA4
PB5
PA5
PB4
PA6
PB3
PA7
PB2
PB0
PB1
C138
1
10V
B:CHIP
C140
0.01
B:CHIP
OUT
VDD
VSS
N.C.
4
UD0
R125
15k
:CHIP
X103
24MHz
C161
0.1
25V
B:CHIP
3
RESET
DVDD
R172 15 :CHIP
R173 15 :CHIP
Q105
DTC144EKA
SW
4
DGND
CS1
DGND
23 24 25 26 27 28 29 30 31 32 33
CS3
CS4
CS5
CLKSEL
PP1
DVDD
PP2
DVDD
PP3
PVSEL
R171 15 :CHIP
R168
10k
:CHIP
R169
#
R124
15k
:CHIP
PP4
2
3
4
DS1+
DS1-
R170 15 :CHIP
PSSEL
5
US+
US-
DGND
6
US+
US-
CS2
7
TP102
DVDD
8
TP101
R151
0
:CHIP
R150
0
:CHIP
C143
0.01
B:CHIP
C159
R153
33p
1M
CH:CHIP :CHIP
C162
22
6.3V
:AL-CP
8
C154
0.1
25V
B:CHIP
11 10 9
1
PP5
R152
1.5k
:CHIP
2
6
R192
10k
:CHIP
IC127
µPD72012GB-003-3B4
USB HUB CTRL
C144
0.1
25V
B:CHIP
3.3V -1
17 16 15 14 13 12 11 10 9
Q106
DTC144EKA
SW
C155
0.1
25V
B:CHIP
IC125
ST72T631L4M1 R189
0
USB PJ CTRL :CHIP
C157
0.1
25V
B:CHIP
+5V
C141
0.1
25V
B:CHIP
44
43
42
41
40
39
38
37
36
35
34
R194
100
:CHIP
C156
0.1
25V
B:CHIP
FB136
BLMP750S
1
VBUS
OUT2
IN
GND
OUT1
2
R142
510k
:CHIP
R145
510k
:CHIP
CTL2
FLG2
FLG1
CTL1
5V -1
TO (1/2)
USB5V
C142
100
6.3V
:AL-CP
5
1
2
R195
2.2k
:CHIP
3
R129
1k
:CHIP
C163
22
6.3V
:AL-CP
4
R196
#
IC128
µPD16875G-E2
USB POWER SUP
+3.3V
Q107
2SA1162
SW
3
D133
RB501V
FB139
BLMP750S
C139
0.1
25V
B:CHIP
R149 15k :CHIP
DS2+
DS2-
US-
US+
VBUS
DS1-
DS1+
R183 15k :CHIP
DS2+
DS2DS3+
DS3-
R182 15k :CHIP
A TYPE USB
J121
FB123
BK2125HM601
FB122
FBMH3216HM501NT
DS2DS2+
1
JL123 #
2
3
JL125 #
FB124
BK2125HM601
4
TO (1/2)
FB127
FBMH3216HM501NT
JL124 #
D126
RD5.6SB-T1
JL127
#
JL117
#
FB128
BK2125HM601
FB126
0
:CHIP
FB125
D124
FBMH3216HM501NT UDZ-TE-17-3.9B
B TYPE USB
D125
UDZ-TE-17-3.9B
J122
FB132
BK2125HM601
JL130
#
D136
#
4
D129
UDZ-TE-17-3.9B
D130
UDZ-TE-17-3.9B
FB131
FBMH3216HM501NT
FB133
0
:CHIP
FB134
0
:CHIP
R126
#
QA(2/2)
(A/B USB CONNECTOR)
B-SS1697<08.>-QA.-P2
S-80842ANNP (IC124)
VOO
2
5
1
OUT
VREF
VSS
4
8-6
A
B
C
D
8-6
VPL-CS1
E
F
G
H
BA
BA
CXA1875AM-T4 (IC201)
SCL
SDA
SAD2
SAD1
SAD0
SW3
SW2
16
15
14
13
12
11
10
9
VERTICAL
BORDER EMPHA
1
B-3
C-2
A-3
D-2
B-1
∗ C-2
+
-
ADAPTIVE
FILTER OP
LATCH
LATCH
LATCH
LATCH
LATCH
DAC
DAC
DAC
DAC
DAC
D/A
9 AYO
D/A
7 ACO
LOGICAL OPERATION
4fsc
–
+
2
VCC
REG
AMP
AMP
AMP
AMP
AMP
PHASE
COMPARATOR
VCO
SW
1/4
SW
1/2
1
2
3
4
5
6
7
8
GND
3
DAC0
B-1
2
+
-
CLAMP
POWER
ON
RESET
DAC1
X301
NTSC:1H
PAL :2H
I2C DECODER
DAC2
D-2
D-2
D-2
C-1
NTSC:1H
PAL :2H
A/D
DL
B-2
A-2
A-1
A-1
A-1
A-1
C-2
D-2
D-2
B-2
C-2
TP271
TP272
TP273
TP274
ADIN 2
CLPO 1
LEVEL
CONVERTER
DAC3
∗
∗
OPEN COLLECTOR
LEVEL
CONVERTER
LATCH
DAC4
∗
∗
∗
LEVEL
CONVERTER
SW0
Q221
Q222
Q226
Q227
Q228
Q229
Q271
Q272
Q273
Q302
Q303
A
SW1
IC201
IC202
IC221
IC271
IC301
IC302
B
C
VCC
D
——
BA
——
1-675-793-11
1
CXD2064Q-T6 (IC221)
42
44
39
37
38
CPO
VCV
PLSL
FIN
CKSL
BA – B SIDE –
SUFFIX ; -11
*:B Side mount
CXA1839Q (IC271)
GND
Y1-IN
RY1-IN
BY1-IN
GND1
VCC1
YUV-SW
VM-MUTE
SP-MUTE
VM-OUT
CLP-C
APED-C
3
36
35
34
33
32
31
30
29
28
27
26
25
BY2-IN 37
A
C
B
D
24 AP-MUTE
RY2-IN 38
Y
YUV-SW
NR
Clamp
DPicture
VM Amp
Sharpness
B-Y
R-Y
NC 40
1
1REF 41
21 CBLK
Y
R-Y
B-Y
Hue
Color
CEC
IREF
Axis
R-Y
G-Y
B-Y
Matrix
Clamp
Pulse
Interface
C-OFF 42
GND 43
18 VEQ
R G B
D-Color
Bright
R
G
B
YS2
YM2
Picture
Clamp
17 VBLK
YS1
YM1
16 VTIM
BOUT 46
15 SSCP
8
9
10
11
12
YS1
7
LB1-IN
6
LG1-IN
LB2-IN
5
LR1-IN
LG2-IN
4
VCC2
3
Bus
Dec
GND2
2
YS2
1
LR2-IN
ABL-MUTE 48
Amp
Clamp
YM2
Amp
Clamp
YM1
ABL-REQ 47
2
20 FFTIM
19 VS
ABL
Amp
ROUT 44
GOUT 45
23 CLP1
22 BGP
Y2-IN 39
4
14 SCL
13 SDA
3
BA Board Waveforms
BA – A SIDE –
1
SUFFIX ; -11
2
3
5
0.6 Vp-p
TP271 [V-R]
8-7
VPL-CS1
A
B
C
D
0.6 Vp-p
TP272 [V-G]
0.6 Vp-p
TP273 [V-B]
8-7
E
F
G
H
BA
BA
5V
CN201
70P
V-VD
1
2
3
4
5
V-HD
JL209 #
JL223 #
7
5V
8
FL302
NFM41P11C204
VIDEO
PALV
C333
FL303
C334
47
NFM41P11C204 16V
0.01
:AL-CP B:CHIP
B1
G1
R1
Cr2
Y/C GND
Y2
Cb2
B2
Y/C Vcc
COMB C/FORCED S
D-GND
HS
4
5
6
7
8
9 10 11 12 13 14
SCL
VR-Y
VB-Y
VY
C318
4.7 C320
35V
:AL-CP 0.1
25V
B:CHIP
C321
0.1 25V B:CHIP
C322
0.1 25V B:CHIP
R318
47
:CHIP
S-C
1
2
3
4
5
Q222
2SA1162
BUFF
6
R223
4.7k
:CHIP
Q227
2SC2712
BUFF
C227
C228
100
0.1
16V
25V
:AL-CP B:CHIP
12
10 9
7
R234
5.6k
:CHIP
R235
560
:CHIP
1.8
R236
0
:CHIP
R239
1k
:CHIP
C226
0.01
B:CHIP
6
1.2
3
2
1
1.5
Q226
2SA1162
FL222
7
9 10
R250
150
:RN-CP
12
R242
5.6k
:CHIP
Q229
2SC2712
BUFF
R243
560
:CHIP
1.4
1.8
6
R244
100
:CHIP
5
4
3
2
1
R245
1k
:CHIP
Q228
2SA1162
0.1
FL223
R247
560
:CHIP
Q303
2SC2712
4
R237
1k
:CHIP
0.8
C230
0.1
25V
B:CHIP
1.2
5
R240
#
R321
100
:CHIP
0.1
R314
1k
:CHIP
R319
47
:CHIP
2.9
2.3
FB202
BK2125HS102
COMB Y
5.0
2.3
FL221
+5V
R322
0
:CHIP
R323
#
R227
1k
:CHIP 1.7
R225
560
:CHIP
R231
R230 1.2k
33k :CHIP
:CHIP
0.1
0.1
C224
10
20V
:TA-CP
R228
1k
:CHIP
Q221
2SC2712
BUFF
C225
22
10V
:TA-CP
COMB C
C330
0.01
C328 B:CHIP
1
10V
B:CHIP
R222
22k
:CHIP
SDA
YS3
SYNC-Vcc
SCP
Y FOR SYNC
SYNC-GND
24
23
22
21
20
19
18
17
16
15
R305
100
:CHIP
Q302 R312
100
2SC2712:CHIP
5.0
L226
4.7µH
G2
R2
YS/YM
BPH-Fil
3
C327
0.1
25V
B:CHIP
C332
0.01
B:CHIP
C331
47
16V
:AL-CP
L225
4.7µH
R209
100
:CHIP
R213
100
:CHIP
EMI
JL204 #
2
VIDEO
15K-CS
JL205 #
1
C326
1
10V
B:CHIP
EMI
R208
100
:CHIP
JL221 R214 R207
100
#
100
:CHIP :CHIP
V-CLP
6
R210
100
:CHIP
R211
10k
:CHIP
R212
10k
:CHIP R215
100
:CHIP
JL211 #
C325 0.01 B:CHIP
Cr1
SCL
SDA
JL210 #
C324 0.022 B:CHIP
Cb1
D-VDD
C323
2.2
6.3V
B:CHIP
IC201
CXA1875AM-T4
DAC
Y1
COMB Y
C202
47
16V
:AL-CP
JL222 #
SCL
JL212 #
JL303 #
R304 3.9k :CHIP
APL FIL
VS
C201
0.1
25V
B:CHIP
SDA
Xtal
R303 0 :CHIP
16 15 14 13 12 11 10 9
JL229
JL213 # #
C319 0.1 25V B:CHIP
JL301 #
Y
Y OUT
JL302 #
R206
100
:CHIP
Cb out
IC301
CXA2123AQ-T6
COLOR DECODER
CVBS OUT(2VPpp)
JL228
#
C338 0.1 25V B:CHIP
C317 0.01 B:CHIP
SYNC IN
R204
100
:CHIP
R203
100
:CHIP
R302
0
S-C :CHIP
S-Y C
YS1
Cr out
CVBS/Y1
SDA
SCL
JL227
#
39 C3
40 APC-Fil
41 CVBS/Y3
42 ADD(8EH)
43 C2
44 CVBS/Y2
45 COMB SYS
46 SFC OUT
47 AFC.Fi
48 C1
C315
0.01
C222
0.1
25V
B:CHIP
C221
100
16V
:AL-CP
38 37 36 35 34 33 32 31 30 29 28 27 26 25
C313
R310 0.01
27k
:RN-CP B:CHIP
PALV B:CHIP
R202
10k
:CHIP
R248
#
7
9 10
12
R249
150
:RN-CP
R313
100
0.3 :CHIP
R315
1k
:CHIP
JL216 #
R324
47
:CHIP
4
5
3
C235
Y/R-Y/B-Y
R317
6.8k
:CHIP
0.1
V-HD
V-VD
VIDEO
4.8 5.0
1
JL215 #
R320
47
:CHIP
2.9
2
S-Y
IC302
TC75S56F
V-CLP
C304 R309
3.3k
0.1 :RN-CP
25V
B:CHIP
R311
4.7k
:RN-CP
0.1
25V
B:CHIP
R251
1.5k
:CHIP
C233
0.1
25V
B:CHIP
R252
3.3k
:CHIP
C237
0.1
25V
B:CHIP
JL214 #
VY
VR-Y
VB-Y
JL224 #
INPUTA/VIDEO
5V
Q271
HN1B01FU-TE85R
BUFF
R293
0
:CHIP
8
6
7
0.5
Y
5
1
2
3
4
R218
10k
:CHIP
R299
100
:CHIP
R276
22k
:CHIP
TP271 TP272 TP273
R283
10k
:CHIP
1
0 0
R280
22k
:CHIP
R291
22k
:CHIP
V-R
V-G
V-B
2
3
TP274
APED-C
1
2
3
4
5
6
7
8
PNR
DTR
DVSS
5.0
SDA
5.0
2.6
V-R V-G V-B
VEH1
TEST
GND
R289
100
:CHIP
Q273
HN1B01FU-TE85R
BUFF
VEH2
DVDD
SCL
VCC
R292
33k
:CHIP
VEH3
TEST
WC
E2
C286
0.01
B:CHIP
AP-MUTE
L222
OµH
+5V
C240
0.1
25V
B:CHIP
C242
0.1
25V
B:CHIP
R254
56k
:CHIP
R255
C243
560
0.022
:CHIP B:CHIP
C244
0.001
B:CHIP
25 26 27 28 29 30 31 32 33 34 35 36
5V
C246
0.1
25V
B:CHIP
NTPL1
+5V
IC271
CXA1839Q-T6
RGB DECODER
MOD1
TEST
E1
0 0
R274
27k
:CHIP
DVSS
TRAP
E0
R217
10k
:CHIP
0.5
0.01
B:CHIP
R281
0
:CHIP
R216
10k :CHIP
2.6
24
CLP1 23
BGP 22
CBLK 21
FFTIM 20
VS 19
VEQ 18
VBLK 17
V-TIM 16
SSCP 15
SCL 14
SDA 13
IC221
CXD2064Q-T6
D.COMB
MOD2
APCN
R282
33k
:CHIP
0 0 C285
C300
1
10V
B:CHIP
C284
0.01
B:CHIP
BUFF
V-B
IC202
M24C64WMN6T
R286
R278
1k
Q272
680
:RN-CP HN1B01FU-TE85R :RN-CP
37 BY2-IN
38 RY2-IN
39 Y2-IN
40 NC
41 IREF
42 C-OFF
43 GND
44 R-OUT
45 G-OUT
46 B-OUT
47 ABL-REQ
48 ABL-MUTE
DVDD
DVSS
JL208 #
0.5
B-Y
R-Y
Y
C282
0.01
B:CHIP
VB
TEST
TEST
B-Y
R287
1k
:RN-CP
R279
1.5k
:RN-CP
C236
100
16V
:AL-CP
CLVS
DVDD
V-G
R277
R272
33k
220
:CHIP :RN-CP
2.6
R275
0
:CHIP
36 35 34 33 32 31 30 29 28 27 26 25
C283
0.01
B:CHIP
48
CLPEN 47
CLVD 46
PLVD 45
VCV 44
PLVS 43
CPO 42
ADCK 41
MCKO 40
PLSL 39
CKSL 38
FIN 37
IRF
NTPL1
JL207 #
FB271
BK2125HM102
R257
#
1
NTPL2
R273
1.5k
:RN-CP
+5V
LG2-IN
LB2-IN
YS2
YM2
VCC2
GND2
LR1-IN
LG1-IN
LB1-IN
YS1
YM1
V-R
NC
Y1-IN
RY1-IN
BY1-IN
GND1
VCC1
YUV-SW
VM-MUTE
SP-MUTE
VM-OUT
CLP-C
JL206 #
+9V
R256
0
:CHIP
C280
10
16V
:AL-CP
LR2-IN
C281
1
10V
B:CHIP
C276
C277
C278
0.01
0.01
0.01
B:CHIP B:CHIP B:CHIP
2
CLPO
R297
#
C279
1
16V
B:CHIP
3
ADIN
C275
0.1
25V
B:CHIP
4
RB
R296
220
:CHIP
5
ADVS
C271
#
6
ADVD
Y
C241
0.1
25V
B:CHIP
7
RT
JL202 #
L271
OµH
:CHIP
13
14
15
16
17
18
19
VEH3
20
VEH2 21
VEH1 22
23
24
8
ACO
R-Y
R300
100
:CHIP
12 11 10 9
AYO
JL201 #
9V
JL226 C274
#
47
R271 16V
100 :TA-CP
:CHIP
C239
0.1
25V
B:CHIP
DAVS
C273
#
R253
2.2k
:CHIP
5V
C232
0.1
25V
B:CHIP
DAVD
B-Y
JL225
#
C234
0.1
25V
B:CHIP
C238
0.1
25V
B:CHIP
JL203 #
R-Y
5
C314
0.47
16V
B:CHIP
R205
100
:CHIP
L224
4.7µH
R316
3.3k
:CHIP
VG
4
R201
4.7k
:CHIP
JL220 #
JL218 #
R306
330
:CHIP
VRF
VIDEO
VIDEO
GND
GND
B-Y
B-Y
GND
GND
R-Y
R-Y
GND
GND
Y
Y
GND
GND
V-R
V-R
GND
GND
V-G
V-G
GND
GND
V-B
V-B
FB201
BK2125HM102
VEH2
VEH3
C
C
GND
GND
Y
Y
GND
GND
3
5V
5V
C337
0.01
B:CHIP
C302
0.1
25V
B:CHIP
C301
47
16V
:AL-CP
C312
10
16V
X301
:AL-CP 16.2MHz
INPUTA/VIDEO
V-CLP
V-CLP
S-IN
S-IN
15K-CS
15K-CS
PAL-V
PAL-V
GND
GND
+5V
5V
VEH1
SCL
SCL
V-VD
V-VD
V-HD
V-HD
EMI
L221
4.7µH C303
:CHIP 10p
CH:CHIP
JL219 #
0
VCC
0
SCL
0 4.9
SDA
DAC4
0.3 4.9
SDA2
DAC3
0.3
SDA1
DAC2
0.4
SDA0
DAC1
0.4
SW3
DAC0
2.4
SW2
GND
0
2
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A27
B27
A28
B28
A29
B29
A30
B30
A31
B31
A32
B32
A33
B33
A34
B34
A35
B35
SW0
F-DA
F-DA
F-CL
F-CL
F+5V
F+5V
SDA
SDA
FL301
NFM41P11C204
9V
SW1
TO QA BOARD CN104
+9V
+9V
+9V
+9V
GND
GND
A5V
A5V
A5V
A5V
GND
GND
NTPL1
1
15K-CS
• Refer to page 8-7 for Printed Wiring Board
• Refer to page 8-7 for Waveforms
• Refer to page 8-7 for IC Block Diagrams
R284
100
:CHIP
C245
0.1
25V
B:CHIP
R258
0
:CHIP
C247
82
6.3V
L223
4.7µH
R260
#
R259
0
:CHIP
R261
#
SCL
SDA
R285
100
:CHIP
9 10 11 12
GND
C287
0.01
B:CHIP
C291
0.01
B:CHIP
R288 R298 R290
100
100
100
:CHIP :CHIP :CHIP
R294
C292 C293
1k
0.01 0.01
B:CHIP B:CHIP :CHIP
R
G
B
+9V
C296
0.01
B:CHIP
BA
C295
0.01
C297 B:CHIP
0.1
25V
B:CHIP
C294
0.01
B:CHIP
COLOR,DECORDER
R,G,B,DECORDER
D.COMB
B-SS1697<08.>-BA.
8-8
A
B
C
D
8-8
VPL-CS1
E
F
G
H
B
B
1
—
B
—
1-675-794-11
F
G
1
2
3
B-2
A-1
A-1
A-1
B-2
C-1
G-1
X401
X402
X403
∗ E-2
∗ E-3
∗ G-2
*:B Side mount
2A4
∗
∗
∗
∗
∗
∗
∗
1Y4
TP401
TP402
TP403
TP404
TP405
TP406
TP407
2A3
A-1
A-1
G-3
B-3
20
1Y3
∗
∗
∗
∗
74VHC240MTCX (IC402)
2A3
Q401
Q402
Q403
Q405
3.6 Vp-p
TP406 [PICLK]
3.2 Vp-p
TP401 [VSI]
19
18
17
16
15
14
13
12
11
3
S-80842ANNP (IC419)
S-80828ANNP (IC420)
VOO
2
1
1
2
3
4
5
6
7
8
9
10
GND
E
D
6
5
2Y1
C
3.2 Vp-p
TP405 [HSI]
0.6 Vp-p
TP402 [B]
1A4
B
4
2
2Y2
A
∗ B-2
∗ B-1
B-2
A-1
∗ B-2
∗ B-1
D-2
∗ A-1
C-1
∗ D-1
B-1
∗ D-1
∗ C-2
E-1
∗ E-1
∗ E-3
∗ C-2
G-2
∗ F-3
∗ F-3
∗ E-3
G-3
∗ E-2
F-2
∗ E-2
∗ F-2
E-2
∗ D-1
∗ C-3
B-2
0.6 Vp-p
TP403 [G]
3
1Y2
SUFFIX ; -11
IC401
IC402
IC403
IC404
IC405
IC406
IC407
IC407
IC408
IC408
IC410
IC411
IC412
IC413
IC414
IC415
IC416
IC418
IC419
IC420
IC421
IC422
IC423
IC424
IC425
IC427
IC428
IC428
IC429
IC430
2
0.6 Vp-p
TP404 [R]
1A3
B – B SIDE –
∗
∗
∗
∗
∗
∗
∗
∗
∗
∗
2A4
3
A-2
A-2
A-2
A-2
A-2
G-2
F-2
B-2
B-3
B-3
A-2
A-2
C-3
2Y3
2
D401
D402
D403
D404
D406
D408
D409
D410
D411
D412
D413
D414
D415
1
1A2
1
B Board Waveforms
2G
A
1Y1
B
2Y4
C
D
Vcc
E
1G
F
1A1
G
OUT
VREF
4
VSS
SN74CBTD3306PWR (IC410)
4
TC74LCX04FT (IC421)
VCC
10E 1
14
13
12
11
10
9
1
2
3
4
5
6
8
8 VCC
1A 2
1B 3
7 2OE
B – A SIDE –
GND 4
6 2B
5 2A
7
GND
5
SUFFIX ; -11
8-9
VPL-CS1
A
B
C
D
8-9
E
F
G
H
B (1/4)
B (1/4)
• Refer to page 8-9 for Printed Wiring Board
• Refer to page 8-9 for Waveforms
• Refer to page 8-9 for IC Block Diagrams
5V-3
3.3V-2
R401
IC401(6/6) 47 1/16W :CHIP
74VHC14MTCX
15K-CS TO(1/4)
INV
C423
#
C425
#
R425
47
1/16W
:CHIP
GND
OUT(B)
GND
IN2(R)
GND
OUT(SONG)
VCC
IN2(G)
N.C.
N.C.
OUT(H)
GND
OUT(V)
IN2(B)
IN2(H)
GND
IN2(V)
SW
R420
C502
100
100p
CH:CHIP 1/16W
:CHIP
5
10 9
C420
R421 0.1
16V
560
:CHIP B:CHIP
R430
100
1/16W
:CHIP
R429
100
1/16W
:CHIP
D404
MA157-TX
PROTECT
9 10 11 12 13 14 15 16
1
2
3
4
1Q
5
2Q
6
2C
7
2R/C
GND
3.2
1C
0
1Q
2Q
2.6
10
3.2
7
R422
10k
1/16W
:CHIP
IC401(5/6)
74VHC14MTCX
INV
OTHER/RGB
IC406
CXA1875AM
DAC
SW1
SW0
VCC
4.8
SCL
4.8 4.9
DAC4
SDA
4.9
DAC3
SDA2
0.2
DAC2
SDA1
0.4
DAC1
SDA0
4.6
DAC0
SW3
GND
SW2
2CLR
0
0
V-HD
TO(1/2)
CLAMP
TO(2/4)
2B
2A
4.6
0
R412
10k
1/16W
:RN-CP
HSI
TP405
A-R
4
C411
100p
CH:CHIP
A-G
TO(1/4)
R416
10
1/16W
:CHIP
JL410
#
HSI
TO(2/4),(4/4)
A-L
SDAT
SCL
SDA
SCLK
FROM(4/4)
FROM(4/4)
R424
100
1/16W
:CHIP
DAC CS
AUDIO CS
C426
0.1
16V
B:CHIP
AUDIO MUTE
5V-3
JL416
#
FB404
BK2125HM102T
R447
1k
1/16W
:CHIP
R451
1k
1/16W
:CHIP
C572
0.1 2.8
16V
B:CHIP
2.7
IC429
24LC21AT/SN
DDC
2
6
4
5
GND
C/H
C/H DET
V IN
H.POL
CLAMP
VCC
HD
HD
VD
V DET
VS/S OUT
VTIMING
VS/S IN
GATESW
IC407
M52347SYUNC
SYNC SEP
C437
10
16V
:AL-CP
3.0
4.8
4.8
0.3
R434
4.7k
1/16W
:RN-CP
+5V
JL418
#
5V-2
R441
#
0.2
0.2
0.8
1.0
5V -1
C428
220p
CH:CHIP R439
47
1/16W
:CHIP
R442
#
R446
47k
:RN-CP
R443
3.3k R444
1/16W 47
:CHIP 1/16W
:CHIP
C431
0.01
25V
B:CHIP
C432
22
6.3V
:AL-CP
R448
150
1/16W
:CHIP
C438
100p
CH:CHIP
TH201
VCC
2
NC2
VCLK
R453
120
1/16W
:CHIP
TATA+
C440
100p
CH:CHIP
3
NC3
SCL
4
GND
SDA
R592
47
1/16W
:CHIP
5V-3
5V -1
TCLKTCLK+
FB408
#
4.2
R590
100k
:CHIP
C567
0.1
16V
R591
47 B:CHIP
1/16W
:CHIP
TBTB+
TCTC+
Q405
2SA1611-T1-M5M6
POWER SW.
R588
15k
:CHIP
JL422
#
FB409
#
KEY-TH
FROM (4/4)
TDTD+
SCL
R589
47k
:CHIP
FROM (4/4)
SDA
JL486 #
JL487 #
PANEL TEMP
5
LAMP TEMP
D410
RD5.6SB-T1
CN405
32P
WHT
LVDS
FROM (4/4)
8
1
NC1
R587
15k
:CHIP
7
PAL V TO(1/4)
JL488 #
GREENIN
V.POL
R593
220 :CHIP
R596
#
D415
RD5.6SB-T1
C436
0.068
16V
B:CHIP
Q402
HN1B01FU-T
LIMITER
C439
0.1
16V
B:CHIP
R595
470
:CHIP
C441
#
C434
4.7
10V
B:CHIP
2.2
D414
1SS355TE-17
R452
1k
1/16W
:CHIP
2.4
0.7
0.2
1.0
3.4
2.7
CLAMPSW
7
C430
0.1
16V
B:CHIP
R440
1k
1/16W
:CHIP
0.2
3.1
C433
4.7
10V
B:CHIP
H.STATE
V.STATE
3
1
CLAMP
TIMING
8
2.8
D413
1SS355TE-17
C435
4.7
10V
B:CHIP
R438
0
:CHIP
6
R449
0
:CHIP
R437
47k
1/16W
:CHIP
5
4
JL417
#
10 9
D406
MA157-TX
PROTECT
R450
0
:CHIP
C571
0.1
16V
B:CHIP
R436
1k
1/16W
:CHIP
2.2
R435
1k
1/16W
:CHIP
R445
0
:CHIP
Q401
HN1B01FU-T
+5V
LIMITER
R594
470
:CHIP
D412
D411
RD5.6SB-T1 RD5.6SB-T1
KEY0
LED
FROM (4/4)
8
1
7
6
5
2
C581
0.1
16V
B:CHIP
JL408
#
KEY1
PSAVE LED
LAMP LED
TEMP LED
POWER LED
TO QA BOARD CN105
CN403
50P
5V-3
11 12 13 14 15 16 17 18 19 20
C427
4.7
10V
B:CHIP
COAST TO(2/4)
TO C BOARD CN801
3.3V-2
R433
0
:CHIP
IC430
TC7W14FU
INV.
3.3V-2
R431
10k
1/16W
:CHIP
+5V
3.3V-3
JL403
#
C560
2200p
B:CHIP
R407
100
1/16W
:CHIP
R423
100
1/16W
:CHIP
R428
100
1/16W
:CHIP
+3.3V
C403
0.1
16V
B:CHIP
5V-2
R427
10k
1/16W
:CHIP
R597
1k
1/16W
:CHIP
0
3
IC403
TC7SH08FU
AND
TO(1/4)
C429
4.7
10V
B:CHIP
R432
47
1/16W
:CHIP
1CLR
VSI
TO(2/4),(4/4)
0
2.9
OTHER/15K
B-Y
R-Y
Y
VCC
1R/C
3.2
C416
3300p
B:CHIP
14
11
C421
0.1
16V
B:CHIP
R426
82
:RN-CP
3
1B
8
GND
IN1(V) VCC2(B)
R417
100
1/16W
:CHIP
R415
1.5k
1/16W
:RN-CP
9 10 11 12 13 14 15 16
IN1(H)
C415
0.1
16V
B:CHIP
1
OUT(G)
N.C.
2
1
2
3
IN1(B)
N.C.
3
D403
MA157-TX
PROTECT
C424
47
16V
:AL-CP
VCC1(B) VCC2(G)
4
C422
0.01
25V
B:CHIP
IN1(G)
1A
4.8
5
14
10 5
15
N.C.
JL402
#
CN402
50P
IC405
74VHC221AMTCX
MONO MULTI
TO(1/4) V-CLP
6
JL493 #
JL494 #
GND
R408
10k
1/16W
:CHIP
7
9 4
6
8
C419
#
8 3
13
B-Y
CN404
HD15P
12
OUT(R)
3.3
C402
100p
CH:CHIP
R533
100 1/16W :CHIP
JL407
#
+3.3V
C409
0.1
16V
B:CHIP
R413
560
R411 100 1/16W :CHIP
:CHIP
C413
0.1
C500 16V
100p B:CHIP R418
560
CH:CHIP
:CHIP
6
3.2
8
JL401
#
5
5V-2
0.8
C499
100p
CH:CHIP
9
5
R532
100 1/16W :CHIP
8
INPUT-A
Y
VCC1(G)
C418 #
C417
47
16V
:AL-CP
R419
82
:RN-CP
IN1(R)
0
R403
1k
1/16W
:CHIP
G
C407
47
6.3V
:AL-CP
0.3
7 2
C412
0.1
16V
B:CHIP
VCC1(R) VCC2(R)
19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
JL491
#
JL492
#
IC404
M52758FP
VIDEO SW
C408
0.1
16V
B:CHIP
C410
0.1
16V
B:CHIP
R414
47
1/16W
:CHIP
FB403
BK2125HM102T
4
6 1
R410
47
1/16W
:CHIP
D402
MA157-TX
PROTECT
JL490
#
11
R
FB402
BK2125HM102T
C406
47
6.3V
:AL-CP
5
C414
0.01
25V
B:CHIP
B
6
R-Y
+5V
4.6
3.2
0
2.9
0.3
0
3.2
5V-3
7
R409
82
:RN-CP
R405
47
1/16W
:CHIP
8
2
D401
MA157-TX
PROTECT
18 17 16 15 14 13 12 11 10 9
C404
0.01
25V
B:CHIP
C405
47
16V
:AL-CP
4
JL404
#
JL405
#
JL406
#
R406
47
1/16W
:CHIP
C401
0.1
16V
B:CHIP
4
3
4
3
TP404
0
0.2
3.2
0.8
2.9
3.2
0
0
1
2
TP403
R
R404
47
1/16W
:CHIP
1
G
B
TP402
7
V-B
V-G
V-R
G
11 12 13 14 15 16 17 18 19 20
B
2
1
2
1
VSI
TP401
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
TO C BOARD CN803
GND
TATA+
FAN ON
GND
FROM (4/4)
TBTB+
GND
TCTC+
GND
TCLKTCLK+
GND
TDTD+
GND
SCL
GND
SDA
GND
LCD TEMP
GND
LAMP TEMP
GND
KEY0
GND
KEY1
GND
PSAVE LED
LAMP LED
TEMP LED
POWER LED
LAMP SENS
FAN PROT
FAN CONT1
FAN CONT2
LAMP ON
POWER ON
EXT SW
TXD
RXD
B25
A25
B24
A24
B23
A23
B22
A22
B21
A21
B20
A20
B19
A19
B18
A18
B17
A17
B16
A16
B15
A15
B14
A14
B13
A13
B12
A12
B11
A11
B10
A10
B9
A9
B8
A8
B7
A7
B6
A6
B5
A5
B4
A4
B3
A3
B2
A2
B1
A1
A-R
A-R
A-G
A-G
A-L
A-L
GND
GND
SDAT
SDAT
GND
GND
SCLK
SCLK
GND
GND
DAC CS
AUDIO CS
GND
AUDIO MUTE
GND
GND
A+5V
A+5V
A+5V
A+5V
GND
GND
D+3.3V
D+3.3V
GND
GND
SUB+5V
SUB+5V
GND
GND
D+5V
D+5V
R-Y
Y
B-Y
JL412
#
V-R
JL414
#
FROM (1/4)
0
R402
100
1/16W
:CHIP
2
3
IC401(4/6)
74VHC14MTCX
INV
4
0
12
R
IC401(3/6)
IC401(2/6) 74VHC14MTCX
INV
74VHC14MTCX
INV
IC401(1/6)
74VHC14MTCX
3.2 INV
5
IC402
74VHC240MTCX
INV SW
TO (2/4)
TO (1/4)
R531
100 1/16W :CHIP
V-VD TO(1/4)
4.6
13
FB401
BK2125HM601T
3
1
V-G
JL415
#
V-B
PAL V
15K-CS
JL419
#
V-HD
JL420
#
V-VD
JL423
#
GND
GND
LAMP SENS
FAN PROT
FAN CONT1
FAN CONT2
LAMP ON
POWER ON
EXT SW
TXD
RXD
GND
V-CLP
JL489
#
USB REQ
FROM (4/4)
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
GND
JL409
#
GND
R-Y
R-Y
GND
GND
Y
Y
GND
GND
B-Y
B-Y
GND
GND
V-R
V-R
GND
GND
5V -1
JL411
#
3.3V -1
JL413
#
V-G
V-G
GND
GND
V-B
V-B
GND
GND
SDA
SCL
F+5V
F-DA
PALV
PALV
GND
GND
15-CS
15-CS
GND
GND
V-HD
V-HD
V-VD
V-VD
V-CLP
V-CLP
GND
GND
GND
GND
GND
GND
GND
GND
USB REQ
GND
FROM (4/4)
F-CL
LAMP COVER
FILTER COVER
U-DA
NR OFF
U-CL
NF OFF
TO (4/4)
PWR PROT
SIRCS
JL421
#
A-R
TO (1/4)
A-G
A-L
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A27
B27
A28
B28
A29
B29
A30
B30
A31
B31
A32
B32
A33
B33
A34
B34
A35
B35
A+5V
A+5V
A+5V
A+5V
GND
GND
GND
GND
A+3.3V
A+3.3V
GND
GND
D+5V
D+5V
D+5V
D+5V
GND
GND
GND
GND
D+3.3V
D+3.3V
D+3.3V
D+3.3V
GND
GND
GND
GND
SUB+5V
SUB+5V
SUB+5V
SUB+5V
GND
GND
GND
GND
SUB+3V
SUB+3V
SUB+3V
SUB+3V
GND
GND
SDA
SDA
SCL
SCL
TO QA BOARD CN103
CN401
70P
F+5V
F+5V
F-DA
F-DA
F-CL
F-CL
LAMPC
FILC
U-DA
NR OFF
U-CL
NF OFF
GND
GND
PWR PROT
SIRCS
GND
GND
A-R
A-R
A-G
A-G
A-L
A-L
B(1/4)
(R,G,B INPUT,SYNC SEP.)
B-SS1697<08.>-B..-P1
8-10
A
B
C
D
8-10
VPL-CS1
E
F
G
H
B (2/4)
B (2/4)
• Refer to page 8-9 for Printed Wiring Board
• Refer to page 8-9 for Waveforms
• Refer to page 8-9 for IC Block Diagrams
1
+3.3V
IC408
TC74LCX74FT
PICLK
6
5
FB407
BK2125HM601T
R575
#
SCL
FROM (4/4)
9 10 11 12 13 14
1
8
R463
10k 1/16W :CHIP
RB406
100*4
C460
0.1 16V B:CHIP RB407
100*4
G
G
G
G
G
G
G
G
RB408
100*4
C465
0.1 16V B:CHIP RB409
100*4
B
B
B
B
B
B
B
B
FROM (3/4) POFLD
NEW0
NEW1
NEW2
NEW3
NEW4
NEW5
NEW6
NEW7
OLD0
OLD1
OLD2
OLD3
OLD4
OLD5
OLD6
OLD7
C462
0.1
16V
B:CHIP
+3.3V
R467
10k 1/16W :CHIP
R468
10k 1/16W :CHIP
R469
10k 1/16W :CHIP
G AD
TO (3/4)
RB410
100*4
R472
100
1/16W
:CHIP
SRX
1OE
1A
1Y
2
APA CS
SCLK
0
0
5.0
2A
3.2
2Y
0.2
GND
VCC
4 OE
4A
4Y
3 OE
3A
3Y
VDXOUT0
VDXOUT1
VDXOUT2
VDXOUT3
SDIO
XTST
NC NSM
VDD
OUT0
OUT1
OUT2
OUT3
OUT4
OUT5
OUT6
OUT7
OUT8
VSS
OUT9
OUT10
IC412
CXD8774R
APA
R529
10k
1/16W
:CHIP
4.0
3.3
5.0
3.3
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16 17 18 19 20
+3.3V
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
3
R462
10k 1/16W :CHIP
R464
C458 10k 1/16W :CHIP
R466
0.1 10k 1/16W
:CHIP
16V
B:CHIP
JL427 #
JL428 #
4
TO (3/4) B AD
C468
0.1
16V
B:CHIP
NEW7
NEW6
NEW5
NEW4
NEW3
NEW2
NEW1
NEW0
RB412
100*4
B
B
B
B
B
B
B
B
R473
10k
1/16W
:CHIP
RB411
C474 100*4
C475 C473
C472 C471
0.1
0.01
0.22
0.1
0.1
16V
25V
10V
16V
16V
B:CHIP
B:CHIP B:CHIP B:CHIP B:CHIP
61 SELECT1
62 SELECT0
63 VSS
64 HDXOUT
65 HDXIN
66 VPD
67 SDOO
68 FLDOUT
69 FLDIN
70 NC
71 NC
72 NC
73 VDD
74 XACK
75 BCK
76 XTCK
77 SDOOUT
78 SDIIN
79 SCLK
80 SCSIN
IC411
74VHC125MTCX
BUF
SDAT
C470
0.1 +3.3V
16V
B:CHIP
C469
0.1
16V
B:CHIP
DIN30
DIN31
DIN32
DIN33
DIN34
DIN35
DIN36
DIN37
VSS
RESET IN
DIN40
DIN41
DIN42
DIN43
DIN44
DIN45
DIN46
DIN47
VSS
VDX
VD
REFIN
REFOUT
PWRDNB
VD
GND
GND
GND
VDD
GND
NC
HSOUT
DATACK/
DATACK
VDD
GND
DRA0
DRA1
DRA2
DRA3
DRA4
DRA5
DRA6
DRA7
VDD
GND
R474
1.2k
:RN-CP
+3.3V
R460
10k 1/16W :CHIP
R461
10k 1/16W :CHIP
R465
10k 1/16W :CHIP
R554
10k 1/16W :CHIP
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
C466
0.1
16V
B:CHIP
R535
100
1/16W
:CHIP
R470
3.3k
1/16W
:CHIP
R471
3.3k
1/16W
:CHIP
C467
0.1
16V
B:CHIP
R AD
TO (3/4)
+3.3V
FROM (1/4)
CLAMP
+3.3V
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
OLD6
OLD5
OLD4
OLD3
OLD2
OLD1
OLD0
R534
100
1/16W
:CHIP
+3.3V
B
B
B
B
B
B
B
6
C464
0.1
16V
B:CHIP
OLD0
OLD1
OLD2
OLD3
OLD4
OLD5
OLD6
OLD7
FB406
BK2125HM601T
R459
10k 1/16W :CHIP
CLK
VSS
DIN27
DIN26
DIN25
DIN24
DIN23
DIN22
DIN21
DIN20
DIN17
VSS
DIN16
DIN15
DIN14
DIN13
DIN12
DIN11
DIN10
OUT11
8
2
R567
4.7k
1/16W
:CHIP
RB404
100*4
C454
0.1 16V B:CHIP RB405
100*4
G
G
G
G
G
G
G
G
3.3V-2
NEW0
NEW1
NEW2
NEW3
NEW4
NEW5
NEW6
NEW7
NEW7
NEW6
NEW5
NEW4
NEW3
NEW2
NEW1
NEW0
OLD7
VCC
2 EO
2B
2A
3.3V-2
7
1
1 OE
1A
1B
GND
4
SDA
FROM (4/4)
3
R574
#
R566
4.7k
1/16W
:CHIP
C463
0.01
25V
B:CHIP
IC409
AD9884
AD CONVERTER
R
R
R
R
R
R
R
R
TO (3/4)
9 10 11 12 13 14
5V-2
IC410
SN74CBTD3306
BUS SW
C457
0.01
25V
B:CHIP
C459
0.1
16V
B:CHIP
C461
0.068
16V
B:CHIP
DRB0
DRB1
DRB2
DRB3
DRB4
DRB5
DRB6
DRB7
VDD
GND
DGA0
DGA1
DGA2
DGA3
DGA4
DGA5
DGA6
DGA7
VDD
GND
DGB0
DGB1
DGB2
DGB3
DGB4
DGB5
DGB6
DGB7
VDD
GND
DBA0
DBA1
DBA2
DBA3
DBA4
DBA5
DBA6
DBA7
7
B
C456
0.068
16V
B:CHIP
NC
NC
NC
VD
GND
GND
R IN
VD
GND
VD
VD
GND
GND
GND
G IN
VD
GND
VD
VD
GND
GND
B IN
VD
GND
VD
GND
CKINV
CLAMP
SDA
SCL
A0
A1
PVD
PVD
GND
NC
NC
NC
PIHS
JL426
#
FROM (4/4)
R
B
R455
47
1/16W
:CHIP
RB403
100*4
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102
C455
0.1
16V
B:CHIP
38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
8
C453
0.01
25V
B:CHIP
FROM (1/4)
2
C444
22
6.3V
:AL-CP
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
7
6
5
C452
0.068
16V
B:CHIP
G
PICLK TO (3/4)
+3.3V
GND
HSYNC
COAST
GND
PVD
CKEXT
FILT
NC
GND
PVD
GND
PVD
GND
GND
GND
VDD
DBB7
DBB6
DBB5
DBB4
DBB3
DBB2
DBB1
DBB0
GND
VDD
1
4
3
2
C451
0.1
16V
B:CHIP
R
G
2
FB405
BK2125HM601T
C449
0.1
16V
B:CHIP
TO (3/4)
R454
47
1/16W
:CHIP
B
B
B
B
B
B
B
B
B
RB402
100*4
+3.3V
C450
0.1
16V
B:CHIP
PIVS
C442
0.1
16V
B:CHIP
8
RB401
100*4
R458
22
1/16W
:CHIP
C448
0.1
16V
B:CHIP
1
C447
0.1
16V
B:CHIP
2Q
2
R530 C446
0.1
10k
16V
1/16W B:CHIP
:CHIP
2Q
VSI FROM (1/4)
3.2
3
C445
0.1
16V
B:CHIP
GND
4
C443
47
6.3V
:AL-CP
1Q
2D
3.3
2CK
0.2
2PR
5
R456
22
1/16W
:CHIP
L401
6.8µH
1Q
R
R
R
R
R
R
R
R
R457
#
1PR
VCC
2CLR
6
3.3V-3
3
OLD0
OLD1
OLD2
OLD3
OLD4
OLD5
OLD6
OLD7
2.7
1CK
4
3.3V-2
JL425 #
1CLR
1D
5
0.6
1.8
6
JL424 #
7
TP406
FROM (1/4)
5
HSI
COAST
B(2/4)
B AD
TO (3/4)
(A/D CONVERTER)
B-SS1697<08.>-B..-P2
8-11
VPL-CS1
A
B
C
D
8-11
E
F
G
H
B (3/4)
B (3/4)
RB416
10*4
C484
0.1
16V
B:CHIP
3.3V
215 PID21
216 PID22
217 PID23
218 PID24
219 PID25
220 PID26
221 PID27
222 PID28
223 PID29
224 GND
G NEW6
G NEW7
B OLD0
B
B
B
B
B
B
B
B
226 PID31
227 PID32
OLD1
OLD2
OLD3
OLD4
OLD5
OLD6
OLD7
NEW0
228 PID33
229 PID34
230 PID35
231 PID36
232 PID37
233 PID38
234 PID39
235 PID40
C513
0.1
16V
B:CHIP
B
B
B
B
B
B
4
IC417
SCAN CONVERTER
225 PID30
236 GND
237 VDD
NEW1
NEW2
NEW3
NEW4
NEW5
NEW6
238 PID41
239 PID42
240 PID43
241 PID44
242 PID45
243 PID46
B NEW7
244 PID47
245 PIVS
PIVS
PIHS
246 PIHS
247 GND
PICLK
248 PICLK
249 VDD
TO(2/4)
250 PIFLD
POFLD
C519
0.1
16V
B:CHIP
251 PIVSGO
252 SCLK
SC CS
253 SS
254 SI
SDAT
C523
0.1
16V
B:CHIP
SO
CS
DQMO
DQM1
GND
VDD
MD0
MD1
MD2
MD3
GND
MD4
VDD
MD5
MD6
MD7
MD8
GND
VDD
MD9
MD10
MD11
MD12
MD13
GND
VDD
MD14
MD15
MD16
MD17
MD18
GND
VDD
MD19
MD20
MD21
MD22
MD23
GND
VDD
MD24
MD25
MD26
MD27
MD28
GND
VDD
MD29
MD30
MD31
MD32
GND
MD33
VDD
MD34
MD35
MD36
MD37
GND
VDD
MD38
MD39
MD40
MD41
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
SRX
TO (4/4)
4
3
C526
0.1
16V
B:CHIP
0
C527
0.1
16V
B:CHIP
C528
0.1
16V
B:CHIP
C529
0.1
16V
B:CHIP
C530
0.1
16V
B:CHIP
C531
0.1
16V
B:CHIP
C532
0.1
16V
B:CHIP
1
2
3
6
7
8
POCLK
R00
C562
0.1
16V
B:CHIP
+3.3V
OSD-SIG
FROM (4/4)
B07
LVDS
RB525
100*4
3.3V-2
TATA+
TBTB+
L404
2.2µH
C576
0.1
16V
B:CHIP
TCTC+
R577 100 :CHIP
R576 100 :CHIP
TCLKTCLK+
TDTD+
C575
0.01
25V
B:CHIP
C577
22
6.3V
:AL-CP
3.3V-2
RB526
100*4
C579
0.01
25V
B:CHIP
L0403
#
R568
10k
1/16W
:CHIP
C573
0.1
16V
B:CHIP
C574
22
6.3V
:AL-CP
IC413
THC63LVDM83ALVDS
LVDS RECEIVER
SC RST
POCLK
POVS
POHS
C512
0.1
16V
B:CHIP
MA10
MA9
MA8
MA7
MA6
MA5
MA4
C516
0.1
16V
B:CHIP
MA3
MA2
MA1
MA0
C505
0.1
16V
B:CHIP
IC416
SDRAM
C515
0.1
16V
B:CHIP
C517
0.1
16V
B:CHIP
C520
0.1
16V
B:CHIP
MD47
MD46
MD45
MD44
MD43
C521
0.1
16V
B:CHIP
MD0
MD1
MD2
MD3
MD4
MD5
MD6
MD7
MD42
C524
0.1
16V
B:CHIP
IC415
SDRAM
C504
47
6.3V
:AL-CP
MA10
MA0
MA1
MA2
MA3
VDD
VSS
DQ0
DQ15
DQ1
DQ14
VSSQ VSSQ
DQ2
DQ13
DQ3
DQ12
VDDQ VDDQ
DQ4
DQ11
DQ5
DQ10
VSSQ VSSQ
DQ6
DQ9
DQ7
DQ8
VDDQ VDDQ
LDQM
N.C/RFU
WE
UDQM
CAS
CLK
RAS
CKE
CS
N.C
BA
A9
A10/AP A8
A0
A7
A1
A6
A2
A5
A3
A4
VDD
VSS
+3.3V
MD15
MD14
MD13
MD12
C508
0.1
16V
B:CHIP
C518
0.1
16V
B:CHIP
MD11
MD10
MD32
MD33
MD34
MD35
MD36
MD37
MD38
MD39
C510
0.1
16V
B:CHIP
MD9
MD8
C522
0.1
16V
B:CHIP
MA10
MA0
MA9
MA8
MA7
MA6
MA5
MA4
MA1
MA2
MA3
+3.3V
VDD
VSS
DQ0
DQ15
DQ1
DQ14
VSSQ VSSQ
DQ2
DQ13
DQ3
DQ12
VDDQ VDDQ
DQ4
DQ11
DQ5
DQ10
VSSQ VSSQ
DQ6
DQ9
DQ7
DQ8
VDDQ VDDQ
LDQM
N.C/RFU
WE
UDQM
CAS
CLK
CKE
RAS
CS
N.C
BA
A9
A10/AP A8
A0
A7
A1
A6
A2
A5
A3
A4
VDD
VSS
+3.3V
MD47
MD46
MD45
MD44
MD43
MD42
C509
0.1
16V
B:CHIP
MD41
MD40
C511
0.1
16V
B:CHIP
MA9
MA8
MA7
MA6
MA5
MA4
C514
0.1
16V
B:CHIP
MD38
MD39
MD40
MD41
MD34
MD35
MD36
MD37
MD33
MD29
MD30
MD31
MD32
MD24
MD25
MD26
MD27
MD28
MD19
MD20
MD21
MD22
MD23
MD14
MD15
MD16
MD17
MD18
MD9
MD10
MD11
MD12
MD13
MD5
MD6
MD7
MD8
MD4
MD0
MD1
MD2
MD3
1
5
C569
0.1
16V
B:CHIP
4.0
R04
R03
R02
R01
C525
0.1
16V
B:CHIP
IC428
TC7S04FU
INV
2
FROM (4/4) SCLK
256 VDD
+3.3V
FROM (2/4) B AD
FROM (2/4) G AD
5
255 GND
C503
0.1
16V
B:CHIP
B04
B05
B06
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
214 PID20
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56
OLD4
OLD5
OLD6
OLD7
NEW0
NEW1
NEW2
NEW3
NEW4
NEW5
R07
R06
R05
1
3
213 VDD
C507
0.1
16V
B:CHIP
G02
G01
G00
MA9
MA8
MA7
MA6
MA5
MA4
2
G
G
G
G
G
G
G
G
G
G
212 GND
G05
G04
G03
3
211 PID19
MEMCLK
C568
C496 0.1
16V
0.1 B:CHIP
16V
B:CHIP
B00
G07
G06
4
210 PID18
C506
0.1
16V
B:CHIP
MD25
MD24
5
209 PID17
TO P3,P4
C501
0.1
16V
B:CHIP
R477
22
1/16W
:CHIP
MD27
MD26
B03
B02
B01
6
208 PID16
C490
0.1
16V
B:CHIP
7
207 PID15
POHS
MA10
MA0
MA1
MA2
MA3
MD29
MD28
8
206 PID14
POFLD
POVS
TO P2,P3
C578
0.1
16V
B:CHIP
+3.3V
25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
205 PID13
MD31
MD30
4
4
204 PID12
1
203 PID11
2
202 VDD
3
NEW2
NEW3
NEW4
NEW5
NEW6
NEW7
G OLD0
G OLD1
G OLD2
G OLD3
C498
0.1
16V
B:CHIP
R476
22
1/16W
:CHIP
4
201 PID10
+3.3V
FROM (2/4) R AD
R
R
R
R
R
R
200 GND
5
199 PID9
C495
0.1
16V
B:CHIP
6
198 PID8
MD22
MD23
7
197 PID7
R03
R02
R01
R00
8
196 PID6
25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
195 PID5
MD20
MD21
C491
0.1
16V
B:CHIP
+3.3V
194 PID4
C497
0.1
16V
B:CHIP
2
VDD 128
RB418
100*4
POD6 127
GND 126
125
POD5
POD4 124
POD3 123
POD2 122
VDD 121
POD1120
GND119
POD0118
R478 #
POFLD117
JL448
#
POVS116
JL450
#
POHS115
GND114
VDD 113
OSDDT3
OSDDT3112
OSDDT2111 OSDDT2
OSDDT1
OSDDT1110
AVDD 109
AGND108
OSDDT0107 OSDDT0
OSDEN
OSDEN106
POCLK 105
PODMD104
TESTH 103
TEST1102
TEST0101
RST100
MCLKSEL 99
VDD 98
MCLK 97
GND 96
GND 95
VDD 94
MA11 93
MA10 92
MA9 91
MA8 90
MA7 89
MA6 88
MA5 87
MA4 86
VDD 85
GND 84
MA3 83
MA2 82
MA1 81
MA0 80
CAS 79
RAS 78
MWR 77
BA0 76
BA1 75
VDD 74
MD47 73
GND 72
MD46 71
MD45 70
MD44 69
MD43 68
VDD 67
MD42 66
GND 65
193 PID3
25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
PID2
PID1
PID0
POEXT
VDD
GND
POACT
POD47
POD46
POD45
VDD
POD44
GND
POD43
POD42
POD41
POD40
VDD
GND
POD39
POD38
POD37
POD36
POD35
VDD
GND
POD34
POD33
POD32
POD31
POD30
VDD
GND
POD29
POD28
POD27
POD26
POD25
VDD
GND
POD24
POD23
POD22
POD21
POD20
VDD
GND
POD19
POD18
POD17
POD16
VDD
POD15
GND
POD14
POD13
POD12
POD11
VDD
GND
POD10
POD9
POD8
POD7
OLD3
OLD4
OLD5
OLD6
OLD7
NEW0
NEW1
5
MD18
MD19
C489
0.1
16V
B:CHIP
VDD
VSS
DQ0
DQ15
DQ1
DQ14
VSSQ VSSQ
DQ2
DQ13
DQ3
DQ12
VDDQ VDDQ
DQ4
DQ11
DQ5
DQ10
VSSQ VSSQ
DQ6
DQ9
DQ7
DQ8
VDDQ VDDQ
LDQM
N.C/RFU
WE
UDQM
CAS
CLK
RAS
CKE
CS
N.C
BA
A9
A10/AP A8
A0
A7
A1
A6
A2
A5
A3
A4
VDD
VSS
5
MD16
MD17
+3.3V
6
C486
0.1
16V
B:CHIP
RB417
10*4
192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129
R
R
R
R
R
R
R
FB414
BK2125HM601T
7
+3.3V
C487
47
6.3V
:AL-CP
+3.3V
R07
R06
R05
R04
3.3V-2
IC414
MB81F161622B
SDRAM
8
C483
0.1
16V
B:CHIP
G03
G02
G01
G00
G07
G06
G05
G04
B03
B02
B01
B00
RB415
10*4
28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
C481
0.1
16V
B:CHIP
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
C479
0.1
16V
B:CHIP
RB414
10*4
C482
0.1
16V
B:CHIP
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
C478
0.1
16V
B:CHIP
C480
0.1
16V
B:CHIP
1
RB413
10*4
R536 C477
0.1
100
16V
1/16W B:CHIP
:CHIP
2
L402
OµH
JL429
#
3
3.3V-2
C485 0.1 16V B:CHIP
R OLD2
R OLD1
R OLD0
1
B07
B06
B05
B04
• Refer to page 8-9 for Printed Wiring Board
• Refer to page 8-9 for Waveforms
• Refer to page 8-9 for IC Block Diagrams
+3.3V
B(3/4)
C533
0.1
16V
B:CHIP
SCAN CONVERTER,
SDRAM,
LVDS RECEIVER
B-SS1697<08.>-B..-P3
8-12
A
B
C
D
8-12
VPL-CS1
E
F
G
H
B (4/4)
B (4/4)
• Refer to page 8-9 for Printed Wiring Board
• Refer to page 8-9 for Waveforms
• Refer to page 8-9 for IC Block Diagrams
5V -1
+5V
F+5V
F-CL
F-DA
3.3V-2
4
MEMCLK
TO(3/4)
R486
22
1/16W
:CHIP
R487
47
1/16W
:CHIP
VDD
OUT
7
FB411
BK2125HM601T
6
5
3.3V-2
6Y
5A
5Y
4A
GND
4Y
5V -1
8
7
6
VDD
NC
NC
4
VDD
3
5.0
3.3
4.3
R485
47k
1/16W
:CHIP
5
VSS
4
1
1.5
1.6
OUT
2
1
VSS
C542
0.1
16V
B:CHIP
C538
C539
1
0.1
10V
16V
F:CHIP B:CHIP
TO(4/4) CPU_RES
7
6
5
VCC
WC
SCL
SDA
1
2
3
8
5.0
:CHIP
OUT
1
TO(1/4)
Q403
2SB798-DL
RES SW
C535
0.1
R483
16V
1k
1/16W B:CHIP
:CHIP
IC422
#
E0
E1
E2
GND
6A
IC418
TC7W08FU
AND
IC420
S-80828ANNP
RESET
5.0
5.0
2
VDD
1.6
1.5
2A
1.6
2Y
1.4
3A
1.5
3Y
1.5
9 10 11 12 13 14
1
1Y
IC419
S-80842ANNP R481
33k
RESET
1/16W
C536
0.1
16V
B:CHIP
8
R484
22 1/16W :CHIP
1A
2
TO(3/4)POCLK
D409
DAN202K-T-146
R510
10k
1/16W
:CHIP
4
IC421
TC74LCX04FT
INV
3
VDD
OUT
C534
0.1
16V
B:CHIP
OE/ST
GND
R479
10k
1/16W
:CHIP
+3.3V
R482
47
1/16W
:CHIP
D408
DAN202K-T-146
3
FB410
BK2125HM601T
X401
SG-8002JCPCC
52MHz
XTAL
OE/ST
GND
3.3V -1
R480
33k
1/16W
:CHIP
0
1
2
3
4
Q404
2SC2712-YG
RES SW
C540
C541
1
0.1
10V
16V
F:CHIP B:CHIP
R585
10
1/16W
:CHIP
TO(4/4) FWE
OSD-SIG TO(3/4)
RB419
47*4
BUFF
4 15
4.9
IC425(4/8)
5 14
TC74LCX541FT(EL)
0
BUFF
6
OSD CS
SDAT(OSD)
SCLK(OSD)
5.0
IC425(3/8)
TC74LCX541FT(EL)
BUFF
IC425(6/8)
TC74LCX541FT(EL)
BUFF
3
IC425(7/8)
TC74LCX541FT(EL)
BUFF
9
R516
100
1/16W
:CHIP
13
IC425(2/8)
TC74LCX541FT(EL)
BUFF
7 18
IC425(1/8)
TC74LCX541FT(EL)
BUFF
2
17
1
11
3.3V-2
19
20
IC425(8/8)
TC74LCX541FT(EL)
BUFF
8
12
10
C563
0.1
16V
B:CHIP
5V-1
3.3V-1
5V -1 3.3V -1
5
R489
10k
1/16W
X403
:CHIP
XTAL12.288MHz
C546
C547
C545
C549 C551
10p
10p
470p
0.1
0.1 CH:CHIP CH:CHIP CH:CHIP
16V
R490
16V
B:CHIP B:CHIP
3k
:RN-CP
C548
22
6.3V
:AL-CP
R551
10k
1/16W
:CHIP
+5V
R561
10k
1/16W
:CHIP
R550
10k
1/16W
:CHIP
R560
10k
1/16W
:CHIP
C555
22
6.3V
:AL-CP
C556
RB520 0.01
100*4 25V
B:CHIP
C550
22
6.3V
:AL-CP
R500
0
:CHIP
C544
0.1
16V
B:CHIP
+3.3V
90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
91 AVCC
92 VREF
93 AN0/P40
JL454 #
94 AN1/P41
JL455 #
95 AN2/P42
JL456 #
96 AN3/P43
JL457 #
97 AN4/P44
LAMP SENS
JL458 #
98 AN5/P45
FAN PROT
FROM (1/4)
JL459 #
FAN CONT1
99 DA0/AN6/P46
JL460 #
100 DA1/AN7/P47
FAN CONT2
RB521
100*4
101
FROM (1/4) FILTER COVER
AN8/P90
JL482 #
JL481 #
LAMP COVER
102 ANP/P91
5V-2
103 AN10/P92
R549 R548
R557
100
R509
100
104 AN11/P93
1k
10k
1/16W 1/16W 1/16W
1/16W
:CHIP :CHIP :CHIP
105 AN12/P94
:CHIP
106 AN13/P95
R552
JL479 #
#
107 AN14/P96
JL480 #
108 AN15/P97
109 AVSS
R562 100 1/16W :CHIP
TO (3/4) SC RST
110 P70
RESN
111 P71
OSD ON
112 P72
JL433
TRE
#
113 P73
R584
R583 100 1/16W :CHIP
TO (1/4) PWR PROT
10k
114 P74
1/16W
R547 100 1/16W :CHIP
JL476 #
:CHIP
115 SCK3
SCLK
R546 100 1/16W :CHIP
JL477 #
TO (2/4),(3/4)
116 RXD3
SRX
R545 100 1/16W :CHIP
JL478 #
117 TXD3
SDAT
R512
10k
R563
118 MD0
1/16W
10k
:CHIP
1/16W
119 MD1
:CHIP
R513
120 MD2
10k
PVCC1
OSC2
OSC1
VSS
EXTAL
VCC
XTAL
FWE
STBY
NMI
RES
PLLVSS
PLLCAP
PLLVCC
WDTOVF
PG4
PG3
PG2
PG1
PG0
TXD4
C564
0.1
16V
B:CHIP
KEY0
KEY1
LAMP TEMP
PANEL TEMP
16
0
C554
IC425(5/8)
100p
CH:CHIPTC74LCX541FT(EL)
KEY-TH
TO(1/4)
2
R488
200
:RN-CP
3.3V-2
R511
22
1/16W
:CHIP
TRE
R499
22
1/16W
:CHIP
3.3
C553
0.1
16V
B:CHIP
C570
#
IC426
NC7SZ86P5X
EX OR
PF0
PF1
PF2
PF3
PF4
PF5
PF6
VSS
PF7/ ?
R515
100
1/16W
:CHIP
OSDDT0
OSDDT1
OSDDT2
OSDDT3
1/16W
:CHIP
R514
10k
1/16W
:CHIP
1
2
3
IC427
HD64F2633
MAIN CPU
4
5
6
7
8
5V -1
5V -1
RXD4
SCL0
SDA0
SCL1
VSS
SDA1
PVCC2
RXD0
TXD0
PD7
PD6
PD5
PD4
PD3
PD2
PD1
PVCC1
PD0
VSS
PE7
PE6
PE5
PE4
PE3
PE2
PE1
PE0
TIOCB2
P16
TCLKC
JL453 #
PC0
PC1
PC2
SCL
VSS
SDA-OUT
VCC
SDA-IN
PC6
ZOOM
VSS
PB0
PVCC1
PB1
PB2
PB3
PB4
PB5
PB6
PB7
PA0
TXD2(FWR)
RXD2(FWR)
SCLK
VSS
P10
P11
P12
P13
IRQ0
R498
#
DA0
DA1
DA2
DA3
VOBA
VSS
DCLK0
VDD
DB0
DB1
DB2
DB3
VOBB
BISY
4
4
5
6
7
8
14 13 12 11 10 9
R497
47
1/16W
:CHIP
3.3
3.3
GND
+3.3V
4.9
3Y
FROM (3/4)
POVS
R495
1k
1/16W
:CHIP
OSD ON
RESN
4.9
3A
6A
3.3
2Y
VDD
3.1
6Y
0
5A
0
5Y
3.2
4A
1.0
4Y
0.9
8
1
3
2A
4
1Y
5
C552
#
1A
6
R496
47
1/16W
:CHIP
3.0
0
0
3.1
1.4
1.0
7
R544
22
1/16W
:CHIP
2
R492
0
:CHIP
FROM (3/4)
POHS
9 10 11 12 13 14
IC423
74VHCT04MTCX FB412
INV
BK2125HM601T
C558
22
6.3V
:AL-CP
C559
0.1
16V
B:CHIP
3.3V-2
CS
SIN
SCLK
VSS
DCLK1
VSS
VDD
TCLK1
VDD
HSYNC
VSYNC
DISP
RESET
TEST
15 16 17 18 19 20 21 22 23 24 25 26 27 28
3
2
1
FB413
BK2125HM601T
C537
0.01
25V
B:CHIP
OSDEN
IC424
MB90098
OSD
1
3.3V-2
2
C543
0.1
16V
B:CHIP
3
X402
SG-8002JCPCC
70MHz
XTAL
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
R503
2.2k
1/16W
:CHIP
R504
100
1/16W
:CHIP
R538
10k
1/16W
:CHIP
R537
10k
1/16W
:CHIP
R539
10k
1/16W
:CHIP
U-CL
R505
R506
2.2k
100
JL483 #
1/16W 1/16W
:CHIP :CHIP
C557
R540
0.1
100
JL484 #
16V
1/16W
B:CHIP
:CHIP
R541 100 1/16W :CHIP
TO (1/4),(2/4)
U-DA
R543 100 1/16W :CHIP
JL464 #
TXD
EXT SW
TO (1/4)
AUDIO MUTE
AUDIO CS
DAC CS
APA CS TO (2/4)
SC CS
C561 RB524
0.1 100*4
16V
B:CHIP
RB523
100*4
TO (3/4)
JL468
#
LED
TO (1/4)
JL465 #
USB REQ
POWER ON
LAMP ON
JL467 #
TO (1/4)
POWER
TEMP
LAMP
PSAVE
LED
LED
LED
LED
JL461
#
RB522
100*4
R564
10k
1/16W
:CHIP
3
RXD
R542 100 1/16W :CHIP
4
R565
10k
1/16W
:CHIP
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
+3.3V
+5V
GND
NR OFF
NF OFF
JL471 #
JL472 #
JL473 #
R521
10k
1/16W
:CHIP
R524
2.2k
1/16W
:CHIP
CPU_RES
R523
100
1/16W
:CHIP
FROM (4/4)
R525
2.2k
1/16W
:CHIP
R507
100
1/16W
:CHIP
JL462 #
F-DA
F-CL
FWE
JL474 #
R508
100
1/16W
:CHIP
TO (1/4)
JL463 #
JL475 #
R528
100
1/16W
:CHIP
R527
100
1/16W
:CHIP
R501
100
1/16W
:CHIP
R526
100
1/16W
:CHIP
R502
100
1/16W
:CHIP
R555
2.2k
1/16W
:CHIP
HSI
VSI
JL452 JL451 #
#
SCLK(OSD)
5V -1
SDAT(OSD)
R518
100
1/16W
:CHIP
FROM (1/4)
JL470 #
R517
100
1/16W
:CHIP
JL485 #
POVS
1
2
3
4
5
6
7
8
R522
R520
100
100 1/16W
1/16W :CHIP
:CHIP
R553
100
1/16W
:CHIP
FROM (3/4)
FLASH
GND
TXD
RXD
RES
VIN
FWR
MD1
MD2
R519
10k
1/16W
:CHIP
R559
100
1/16W
:CHIP
R558
100
1/16W
:CHIP
SIRCS
FROM (1/4)
TO (1/4)
5V -1
CN406
8P
WHT
:SMD
R491 C566
100
0.1
1/16W 16V
:CHIP B:CHIP
OSD CS
TP407
C565
0.1
16V
B:CHIP
5
5V-2
R556
2.2k
1/16W
:CHIP
JL466 #
SDA
SCL
TO (1/4),(2/4)
JL469 #
B(4/4)
(MAIN CPU)
B-SS1697<08.>-B..-P4
8-13
VPL-CS1
A
B
C
D
8-13
E
F
G
H
C
1
D801
D802
D803
D804
D805
D806
D807
D812
D813
D814
2
3
4
A
—
C
—
1-675-791-11
IC801
IC802
IC803
IC804
IC805
IC806
IC807
IC808
IC808
IC810
IC811
IC812
IC813
IC814
IC815
IC817
IC819
IC820
IC821
IC822
G-3
∗ D-4
∗ D-4
∗ C-4
∗ C-4
∗ C-4
∗ C-4
G-2
G-2
G-2
1
F-3
F-4
A-2
G-2
B-2
B-3
B-3
C-2
D-2
D-2
C-2
C-1
C-4
B-3
D-3
E-4
G-3
G-3
G-4
D-2
2
∗ A-3
B-4
B-4
C-3
C-3
B-3
B-4
D-3
D-3
G-4
F-4
G-3
∗ A-3
∗ A-3
G-4
∗ A-3
G-3
Q801
Q802
Q803
Q804
Q805
Q807
Q808
Q808
Q809
Q810
Q811
Q812
Q814
Q815
Q816
Q817
Q819
TP801
TP802
TP803
TP804
TP805
TP806
TP807
TP808
TP809
TP810
TP811
TP812
TP813
TP814
TP815
TP816
G-2
G-2
A-3
A-3
A-3
C-4
E-3
C-2
B-3
E-4
E-4
B-4
B-2
B-2
A-2
A-2
B
C
D
E
C
F
G
3
4
C – B SIDE –
SUFFIX ; -11
A
B
C
D
E
F
G
1
2
*:B Side mount
3
5
4
C – A SIDE –
SUFFIX ; -11
8-14
A
B
C
D
8-14
VPL-CS1
E
F
G
H
C (1/5)
C (1/5)
• Refer to page 8-14 for Printed Wiring Board
• Refer to page 8-20 for Waveforms
• Refer to page 8-20 for IC Block Diagrams
R824
100
:CHIP
JL872 #
JL812
#
D807
D805
DTZ-TT11-5.1 DTZ-TT11-5.1
D804
DTZ-TT11-5.1
D806
DTZ-TT11-5.1
C831
1
10V
B:CHIP
GND
R823
4.7k
:CHIP
JL809 C834
0.01
#
B:CHIP
4.3
14 10
9
8
7
R826
100
:CHIP
IC804(3/4)
TC74VHC08F
AND
C829
0.01
B:CHIP
POWER ON
1
2
3
4
5
6
NC
5V-2
R807
47
:CHIP
R810
47
:CHIP
TH802
LCD
R813
47
:CHIP
R812
47
:CHIP
R811
47
:CHIP
JL810
#
4.9
4.9
CLP
FROM (2/5)
GND
VCC1(G)CONT REF
OSD G MAIN BRT
GND1(G) B OUT
B IN
2.6
2.2
GND
4.4
VCC1(B)CONT DAC
BLK
OSD B
GND(B)
D/A 1
1.8
NC
D/A 2
GND1(B)
D/A 3
ABL IN
D/A 4
NC
D/A 5
VCC 5V
SOG OUT
CLP
0.6
GND
SDA
5.0
SCL
5.0
G OUT
4.4
1.8
3
KEY0
B
R854 JL882 TP803
0
TO (4/5) LAMP TEMP
:CHIP #
B OUT
R818 R913
#
470
:CHIP
C839
#
R1002 R1012
10k
470
:CHIP :CHIP
Q815
2SA1462
BUFFER
C840
0.1
25V
B:CHIP
R829
47k
:CHIP
Q817
2SA1462
BUFFER
C807
0.22
25V
B:CHIP
C812
C816 0.22
25V
#
B:CHIP
R833
470k
:CHIP
R827
100
:CHIP
RCLK+
RCLK-
R828
100
:CHIP
VD
FAN PROT
R905
100
:CHIP
4
RC+
RCRB+
RB-
HD
TP813 TP814
5
FAN CONT1
RA+
RA-
TO (5/5) A-SCLK
FB803
BK2125HM601T
5V-3
3.3V-2
R847 330 :CHIP
5V-2
FB805
BK2125HM601T
RC+
RCLK+
CN809
5P
WHT
:SMD
RDRD+
R850
JL825 100
:CHIP
#
1
2
3
4
5
JL826
#
R851
100
:CHIP
R1015
100
:CHIP
R1016
100
:CHIP
R1017
100
:CHIP
RXD
TXD
EXT SW
R852
100 :CHIP
D813
DTZ-TT11-5.1
D814
D812
DTZ-TT11-5.1 DTZ-TT11-5.1
G0
G1
G2
G3
G4
G5
G6
G7
G8
G9
BLANK
SYNC
VREF
COMP
IOR
IOR
IOG
IOG
VAA
VAA
IOB
IOB
GND
GND
IC806
ADV7123KST140
D/A
R1022
3.3k
:CHIP
R834
#
EMI
R840
#
R1011
150
:RN-CP
R835
#
G DA
TP816
R831
75
:RN-CP
EMI
FL803
ZJSM-R15-180T
JL884 R832
75
#
:RN-CP
B DA
EMI
FL804
ZJSM-R15-180T
TP817
4
IC807
µM385MX-1.2
REF
JL885
#
R841
75
:RN-CP
C852
0.001
B:CHIP
5
IC805
THC63LVDF84A
LVDS RECEIVER
C850 C851
0.01 0.1
B:CHIP 25V
TO P2 B:CHIP
R1019
0
:CHIP
R1018
22
:CHIP
C(1/5)
CLK
R830
22
:CHIP
LCD DRIVER,
AUDIO AMP
TO P2
B-SS1697<08.>-C..-P1
8-15
VPL-CS1
A
B
3
R DA
FL802
ZJSM-R15-180T
R1009 150 :RN-CP
R1010
150
:RN-CP
2
TP815
JL883
#
3
48
47
46
45
44
43
42
41
40
39
38
37
R9
R8
R7
R6
R5
R4
R3
R2
R1
R0
PSAVE
RSET
1
2
3
4
3
5
R1014
100
:CHIP
C971
0.1
25V
B:CHIP
25 26 27 28 29 30 31 32 33 34 35 36
RB+
RC-
C970
0.1
25V
B:CHIP
RXD
TXD
EXT SW
POWER ON
LAMP ON
FAN CONT2
FAN CONT1
FAN PROT
LAMP SENS
TO B BOARD CN403
GND
RXD
TXD
EXT SW
POWER ON
LAMP ON
FAN CONT2
FAN CONT1
FAN PROT
LAMP SENS
GND
GND
D+5V
D+5V
GND
GND
SUB+5V
SUB+5V
GND
GND
D+3.3V
D+3.3V
GND
GND
A+5V
A+5V
A+5V
A+5V
GND
GND
AUDIO MUTE
GND
AUDIO CS
DAC CS
GND
GND
SCLK
SCLK
GND
GND
SDAT
SDAT
GND
GND
A-L
A-L
A-G
A-G
A-R
A-R
13 VAA
14 B0
15 B1
16 B2
17 B3
18 B4
19 B5
20 B6
21 B7
22 B8
23 B9
24 CLOCK
R846 330 :CHIP
R1013
100
:CHIP
5
R844 330 :CHIP
L814
4.7µH
R1021
560
:CHIP
R1020
0
:CHIP
6
RA+
RB-
R843 330 :CHIP
VCC
RC2
RC1
RC0
GND
RB6
RD5
RD4
VCC
RB5
RB4
RB3
GND
RB2
RD3
RD2
VCC
RB1
RB0
RA6
GND
RA5
RD1
RA4
RA3
VCC
RA2
RA1
7
LED
LED
LED
LED
RC3
RD6
RC4
GND
RC5
RC6
RD0
LVDS GND
RARA+
RBRB+
LVDS VCC
LVDS GND
RCRC+
RCLKRCLK+
RDRD+
LVDS GND
PLL GND
PLL VCC
PLL GND
/PDWN
CLKOUT
RA0
GND
8
PSAVE
LAMP
TEMP
POWER
8
RA-
KEY1
C967 C968
0.1
0.01
B:CHIP 25V
B:CHIP
C828
0.1
25V
B:CHIP
12 11 10 9
2
JL821
#
JL822
#
JL823
#
JL824
#
7
KEY0
R837 1k :CHIP
R839 1k :CHIP
6
TO (2/5)
HSO
VSO
28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
JL819
#
JL820
#
C833
0.01
B:CHIP
C969
47
6.3V
:AL-CP
4
5V-1
RCLK-
VISCA
C818
0.01
B:CHIP C817
0.1
C846
25V
0.001
B:CHIP
B:CHIP
C845
0.001
B:CHIP
FB804
BK2125HM601T
1
2
3
4
5
6
PSAVE LED 7
LAMP LED 8
TEMP LED 9
POWER LED 10
11
D 5V
12
GND
SUB 5V
RXD
TXD
GND
EXT SW
C827
0.001
B:CHIP
1
CN808
12P
WHT
:SMD
C819
0.1
25V
B:CHIP
L804
2.2µH
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56
L803
2.2µH
C825
47
6.3V
:AL-CP C824
0.01
B:CHIP
GND
N.C
KEY0
KEY1
SUB 5V
N.C.
LCD TEMP
RD+
RD-
3.3V-2
TO H BOARD CN001
KEY1
R1007 R1008
Q814 2.2k 2.2k
2SA1462:CHIP :CHIP
BUFFER
C838
0.1
25V
B:CHIP
R912 R1001
470
470
:CHIP :CHIP
FAN CONT2
JL813
#
R825
100
:CHIP
C843
10
C823 16V
# :AL-CP
JL808
#
TP802
SOG IN
G
R853 JL818 TP804
0
TO (3/5)
:CHIP #
CN801
50P
WHT
A1
B1
A2
B2
A3
B3
A4
JL869 B4
# A5
B5
JL870
A6
#
D+5V
JL878
B6
#
5V-2
A7
B7
A8
SUB+5V
B8
5V-1 JL880
#
A9
B9
A10
D+3.3V JL879
B10
#
3.3V-2
A11
B11
A+5V
A12
5V-3 JL877
B12
#
A13
B13
A14
B14
A15
B15
TO (5/5)
A16
AUDIO-MUTE
B16
JL875
#
TO (5/5) APCE
A17
TO (3/5) DALD
B17
A18
B18
JL876
13 0
#
11
A19
12 0
D-SCLK
B19
0
TO (3/5)
A20
IC804(4/4)
TC74VHC08F
B20
JL881
AND
#
A21
SDAT
TO (3/5),(5/5)
B21
A22
B22
A23
B23
A-L
R970
0
A24
:CHIP
TO (5/5) AUDIO GND
B24
A25
B25
A-R
8
C830
47
6.3V
:AL-CP
G IN
2
7
4.7k
:CHIP
CN804
6P
WHT
:SMD
LCD TEMP
TP801
G OUT
R814
#
R OUT
R1005 R1006
2.2k 2.2k
:CHIP :CHIP
POWER LED
TEMP LED
LAMP LED
PSAVE LED
TO B BOARD CN405
32 POWER LED
31 TEMP LED
30 LAMP LED
29 PSAVE LED
28 GND
27 KEY1
26 GND
25 KEY0
24 GND
23 LAMP TEMP
22 GND
21 LCD TEMP
20 GND
19 SDA
18 GND
17 SCL
16 GND
15 RD+
14 RD13 GND
12 RCLK+
11 RCLK10 GND
9 RC+
8 RC7 GND
6 RB+
5 RB4 GND
3 RA+
2 RA1 GND
6
5V-1 R822
TH801
LAMP
JL806
#
R821
2.7k
:RN-CP
NC
GND2
R845 JL817 TP805
0
TO (4/5)
:CHIP #
2SA1462
BUFFER
C836
0.1
25V
B:CHIP
R1000
470
C837 :CHIP
#
R911
470
:CHIP
R
5
R820
100
:CHIP
SUB+5V
C826
0.01
B:CHIP
JL811
#
1
2
3
4
5
C820
0.01
B:CHIP
LAMP SENS
D803
DTZ-TT11-5.1
TO GBA BOARD CN674
POWER CONT
FAN PROT
FAN CONT1
FAN CONT2
GND
R819
#
JL805 #
JL807 #
FB802
BK2125HM601T
C842
10
16V
C822 :AL-CP
47
6.3V
:AL-CP
M.OUT
LAMP TEMP
C821
#
GND1(R)
2.6
2.2
C815
#
JL804
#
1
2
IC804(2/4)
D802
DTZ-TT11-5.1 TC74VHC08F 3
AND
LAMP ON
OSD R
1
1
CN806
3P
WHT
:SMD
CN807
5P
WHT
:SMD
4.9
5.0
VCC1(R)
11.9
R OUT
2.2
2.6
R815
1k
:RN-CP
R817
1k
:CHIP
RIN
VCC2
CN803
32P
WHT
+12V
2
4
5V -1
C841
10
16V
:AL-CP
OSDBLK
R808
#
R1003 R1004
C810 C811 2.2k 2.2k
#
# :CHIP :CHIP
C835
#
Q801
4
BALAST
1
2
3
4.7 6
C809
#
C814
47
6.3V
:AL-CP
IC803
M52749FP L801
RGB AMP 100µH
C801
39
16V
:OS
22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
100
:CHIP
JL803
#
LAMP
SCI
GND
FLAG
IC804(1/4)
TC74VHC08F
AND 5
C832
0.01
B:CHIP
C808
47
6.3V
:AL-CP
C805
47
25V
:AL-CP
+5V
5V-2
R836
100
:CHIP
L802
10µH
7
D801
DTZ-TT11-5.1 R816
1
2
Q816
DTC144EKA
SW
C813
0.1
25V
B:CHIP
FB801
BK2125HM601T
JL871
#
O
G
R806
510
:RN-CP
R909
4.7k
:CHIP
R907
4.7k
:CHIP
I
C803
47
25V
:AL-CP
R802
20k
:RN-CP
R805
4.7k
:CHIP
JL802
#
8
+16.5V
G
21 20 19 18 17 16 15 14 13 12 11 10 9
L CONT OUT
L CONT IN
TEMP
FUSE
R809
0
:CHIP
R803
8.2k
:RN-CP
O
I
C802
47
25V
:AL-CP
JL801
#
1.2
ON/OFF ADJ
EMI
12V
R
CN805
2P
RED
:SMD
AUDIO GND
4.8
R801
10k
:CHIP
FL801
NFM41P11C204
1
12V
B
G
+16.5V
+16.5V
GND
GND
3
4
5
6
7
8
AUDIO +B
R804
0
:CHIP
+12V
IC802
BA12FP
12V REG
VD
HD
AUDIO GND
AUDIO GND
TO (5/5)
AUDIO +B 1
AUDIO +B 2
15.5V
+15.5V
IC801
PQ20VZ5U
15V REG
16.5V
GND
C804
100
16V
:AL-CP
TO GBB BOARD CN706
6
5
4
3
2
1
CN802
8P
WHT
:SMD
C
D
8-15
E
F
G
H
C (2/5)
C (2/5)
• Refer to page 8-14 for Printed Wiring Board
• Refer to page 8-20 for Waveforms
• Refer to page 8-20 for IC Block Diagrams
1
14
HCK1
Y2/SCLK
3.5
5.0
I/11
0
I/01
0
I/02
0.6
4.4
I/015
I/014
C857
1
10V
B:CHIP
4
6
7
1
ENB
1A
2
JL837 R868
# 100
:CHIP
ENB
VST
VST
R870
100
:CHIP
5.9
I/011
0.5
I/010
I/09
4.7
I/012
I/08
SDO/IN1
GND
I/07
I/06
I/05
R860 JL831
#
47
:CHIP
HCK2G
1Y
VCC
2.1 3.9
6A
2.5 0.4
2A
6Y
0.5 4.2
2Y
5A
4.4 0.1
3A
5Y
0 3.9
3Y
4A
0 0.4
GND
4Y
PCG
R867 JL839
47
#
:CHIP
PCG
HST
R869
47
:CHIP
C966
0.1
25V
B:CHIP
HST
TP
TO (3/5),(4/5)
JL840
#
IC822(5/6)
TC74VHCT04AFT
INVERTER
10
4.7
11
PRG
TO (3/5)
R873
100
:CHIP
FL805
#
JL846
#
TO (3/5),(4/5)
IC812
TC7SZ04FU(TE85R)
INVERTER
R875
0
:CHIP
FL806
#
1.5
3.7
3.8
R877
330
:CHIP
VCC
TTL
D
PECL NC
NC
GND
8
NC
Q
1.8
C859
47
6.3V
:AL-CP
Q
R878
330
:CHIP
C861
C860
1
0.1
10V
25V
B:CHIP B:CHIP
2
FROM (1/5) CLK
FB810
BLM21B750S
EMI
R876
22
:CHIP
5
1
FB811
BK2125HM601T
FB809
BLM21B750S
3
3.3V-2
MCLK
MCLK
7
R874
0
:CHIP
JL845 #
FB808
BK2125HM601T
6
JL844 #
5V-2
IC811
MC100ELT20
PECL DRV
EMI
5
JL847
#
+5V
1
JL843 #
2
C858
0.1
25V
B:CHIP
JL842
#
4
JL841
#
CLP
TO (1/5)
PLD
C855
1
10V
B:CHIP
PRG
0.4
1
2
3
4
5
6
7
8
C965
0.1
25V
B:CHIP
R871
47
:CHIP
3
SCLK
GND
MODE
PLUG
ISPEN
SDI
SDO
VCC
C853
1
10V
B:CHIP
HCK2B
+5V
CN810
8P
WHT
:SMD
HCK2R
JL833
#
HCK2
12
13
14
15
16
17
18
19
20
21
22
5.0
I/013
0
9 10 11 12 13 14
VCC
ISPEN
I/04
HCK2
8
1.7
VCK
3
Y1/ RESET
R866
100
:CHIP
VCK
4
VCC
4Y
R857
47
:CHIP
IC810
TC74VHCT04AFT
INVERTER
FROM (3/5)
DWN
RB DIR FROM (3/5)
6
IN2/MODE
IC809
ISPLSI1016E-80LT
44-S
TG
GND
HCK2
R862 JL835
47
:CHIP #
7
0
5.0
I/016
4.7
23 24 25 26 27 28 29 30 31 32 33
0
4.6
I/021
0
I/020
0
I/019
5.5
GND
I/022
I/023
I/018
I/017
I/03
ENB
3.0
0
I/030
0
I/031
0
Y0
5.2
SDI/INO
11 10 9
R872
0
:CHIP
0
0
I/025
0
I/024
0
GOE/IN3
0
1
3
4
5
6
JL838
#
R864
1k
:CHIP
R865
0
:CHIP
C856
1
10V
B:CHIP
I/029
VCC
0.2 0.2
1Y
6A
0.3 0.2
2A
6Y
0.1 0.1
2Y
5A
0.2 0.3
3A
5Y
0.1 0.2
3Y
4A
0.3 0.2
C964
0.1
25V
B:CHIP
7
JL836
#
I/028
2
HSO
FROM (1/5)
I/027
C963
0.1
25V
B:CHIP
I/026
44
43
42
41
40
39
38
37
36
35
34
JL834
#
8
C854
47
R863
6.3V
0
:AL-CP :CHIP
HCK1B
+5V
R861
47
:CHIP
1A
9 10 11 12 13 14
HCK1
JL832
#
1
JL830 R858
47
#
:CHIP
HCK1G
FB807
BK2125HM601T
VSO
FROM (1/5)
HCK1
8
R859
1k
:CHIP
PCG
+5V
R856
47
:CHIP
HCK1R
5V-1
2
IC808
TC74VHCT04AFT
INVERTER
R855
47
:CHIP
7
5
JL827
#
FRP
2
2.5
C962
0.1
25V
B:CHIP
2
1
C961
1
10V
B:CHIP
JL829
JL828 #
#
3
2.1
5V-2
FB806
BK2125HM601T
+5V
5
HCK1
HCK2
HST
VCK
VST
5V-2
IC822(1/6)
TC74VHCT04AFT
INVERTER
4
IC822(3/6)
TC74VHCT04AFT
INVERTER
5
6
IC822(4/6)
TC74VHCT04AFT
INVERTER
9
8
4
3
1.8
C862
0.1
25V
B:CHIP
R879
22
:CHIP
C863
1
10V
B:CHIP
IC822(6/6)
TC74VHCT04AFT
INVERTER
13
C(2/5)
12
LCD DRIVER,
AUDIO AMP
B-SS1697<08.>-C..-P2
5
8-16
A
B
C
D
8-16
VPL-CS1
E
F
G
H
C (3/5)
C (3/5)
• Refer to page 8-14 for Printed Wiring Board
• Refer to page 8-20 for Waveforms
• Refer to page 8-20 for IC Block Diagrams
1
TO (1/5)
TO (4/5)
SDAT
D-SCLK
DALD
DAC
5V-3
FB812
BK2125HM601T
C865
0.1
25V
B:CHIP
C864
47
6.3V
:AL-CP
IC813
MB88346BPFV-EF
12CH DAC
A03
5V-3
R896
4.7k
:CHIP
2.4
R901
470
:CHIP
3
4.7
5
4
1.8
0.6
7
8
0
A011
5.0
VDD
VCC
4
5
R882
100
:CHIP R885
100
:CHIP
R889
100
:CHIP
R890
100
:CHIP
R894
100
:CHIP
R895
100
:CHIP
2
POS-CON2
POS-CON1
FB814
BK2125HM601T
R904
100
R903 :CHIP
100
:CHIP
DLY-CON
SCEN
INV-CON
SID-OUT
DWN
15.5V
L806
1µH
15.5V-2
PRG FROM (2/5)
C870
47
25V
:AL-CP
C869
0.1
25V
B:CHIP
R838
0
:CHIP
JL849
#
2.4
C874
0.1
25V
B:CHIP
+5V
FB816
BK2125HM601T
+15.5V
C875
#
R849
3k
:RN-CP
TP806
C876
#
Q806
HN1B01FU-T
BUFF
R934
100
:CHIP
6.9
R938
Q807
R937
2.2k
:CHIP
R936
0
:CHIP
7.5
R943
0
:CHIP
R944
2.2k
:CHIP
6.9
C895
0.1
25V
B:CHIP
Q809
6.9
R948
2.2k
:CHIP
R949
2.2
HN1B01FU-T :CHIP
BUFF
R947
0
:CHIP
NC
6.9
VCOM OFST
2.0
VCOM OUT
6.5
NC
2.4
0
ISET
1.3
SID-OUT
NC
SID-IN
VCC
3.3
SID-OFST
3.3
2.2
7.0
SH-IN
7.0
FRP
2.5
OFFSET
INV-OUT
VIDEO IN
3.4
SH-OUT4
7.0
NC
CLK-IN
3.4
0.4
SH-OUT5
PRG
7.0
NC
NC
NC
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16
SH-OUT6
JL851
#
C883
0.1
25V
B:CHIP
C884
#
VID1
R917
10
:CHIP
R919
10
:CHIP
R923
10
:CHIP
VID2
C885
#
VID3
G-SID OUT TO (3/5)
GREEN
R926
10 :CHIP
R927
10k
:CHIP
VID4
R929
10 :CHIP
VID5
R930
10 :CHIP
VID6
7.0
VID4
VID3
VID5
VID2
VID6
VID1
JL853
#
24 1
23 2
22 3
21 4
20 5
19 6
18 7
17 8
16 9
15 10
14 11
13 12
12 13
11 14
10 15
9 16
8 17
7 18
6 19
5 20
4 21
3 22
2 23
1 24
7
C890
0.1
25V
B:CHIP
JL854
#
HST
HCK2G
HCK1G
+5V
C893
1000p
B:CHIP
R942
47
:CHIP
TO LCD PANEL(G)
TP808
R932
10k
:CHIP
MCLK
CN811
24P
WHT
5V-2
R940
#
R941
47
:CHIP
R946
2.2
:CHIP
15.5 7.5
NC
CLK-IN
R939
#
MCLK
C892
1000p
B:CHIP
Q808
HN1B01FU-T
BUFF
FROM (4/5) B-SID IN
NC
PGND
DGND
5V-2
R-SID OUT
TO (4/5)
15.5V-3
R945
100
:CHIP
NC
NC
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
C882
100
16V
:AL-CP
3
FB817
BK2125HM601T
JL855
#
FROM (2/5)
6.9
2.2
HN1B01FU-T :CHIP
BUFF
PVCC
IC815
CXA2112R
LCD DRIVER
(G)
NC
R935
2.2
:CHIP
15.5 7.5
FROM (4/5) R-SID IN
C891
0.1
25V
B:CHIP
7.0
CLK-OUT
C881
0.1
25V
B:CHIP
ENB
VCK
VST
PCG
ENB
R933
2.2k
:CHIP
R915
0
:CHIP
NC
R928
#
R931
0
:CHIP
NC
NC
+5V
15.5V-4
7.0
SH-OUT3
CLK-OUT
ENB
GND
SH-OUT2
VDD
5.0
7.5 6.9
C889
#
3.7
INV-CNT
0
NC
C887
C888
47
0.1
6.3V
25V
:AL-CP B:CHIP
TP807
NC
S-12-CNT
R922
0 JL852
:CHIP #
Q805
R925
HN1B01FU-T 2.2
:CHIP
BUFF
GND2
7.0
NC
R924
2.2k
:CHIP
+15.5V
C880
47
25V
:AL-CP
SH-OUT1
MCLK
PRG
6.9
FRP
7.5
3.4
3.4
G-SID OUT
TO (3/5)
4.8
MCLK
NC
6.9
15.5
DLY-CNT
NC
15.5 7.5
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
GND
R921
2.2
:CHIP
TO (3/5) G-SID IN
C886
0.1
25V
B:CHIP
3.7
F/R-CNT
6.3
NEXT-IN
6.9
FB818
BK2125HM601T
Q804
HN1B01FU-T
BUFF
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
C958
10
10V
F:CHIP
5.0
0
4.1
R918
2.2k
:CHIP
R848
820
:CHIP
6
POS-CNT1
5V-2
NEXT-OUT
15.5V-2
R916
0
:CHIP
R920
100
:CHIP
FB815
BK2125HM601T
C878
0.1
25V
B:CHIP
JL850 #
FROM (1/5) G OUT
POS-CNT2
R842
4.7k
:CHIP
L807
1µH
C877
0.1
25V
B:CHIP
C879
10p
CH:CHIP
GINV
SIG CEN
C873
0.1
25V
B:CHIP
R914
27k
:RN-CP
4.4
5.0
C872
#
+15.5V
NC
0
G-SID IN TO (3/5)
IC814
MAX4066CEE
SW
R908
470
:CHIP
2.5
DIR-CNT
Q803
2SA1162
BUFF
6
C871
0.1
25V
R910 B:CHIP
0
:CHIP
D0
A012
R884
5.6k
:CHIP
+5V
R899 C867
0.1
#
25V
B:CHIP
R902
100
:CHIP
9 10 11 12 13 14 15 16
2.4
2.4
R898
#
SH2
2.4
SCEN
4.8
DI
0
CLK
4.0
LD
0
FB813
BK2125HM601T
1
R906
0
:CHIP
6
7
8
R893 R892
100
100
:CHIP :CHIP
R900
0
:CHIP JL848 #
C866
#
2
Q802
2SA1162
BUFF
R883
0
:CHIP
R891
100
:CHIP
R VCOM
B VCOM
R897
#
C868
0.1
25V
B:CHIP
R888
#
10 9
TO (4/5)
R887
#
GND
1.8
A04
2.5
A05
0
A06
0
A07
0
A08
2.0
A09
2.2
A010
2.1
R880
10k
:CHIP
11 12 13 14 15 16 17 18 19 20
1
VSS
3
R881
0
:CHIP
2
15.5V
R886
#
15.5V
B-SID OUT
TO (4/5)
JL856
#
3
4
RB DIR TO (2/5),(4/5)
IC822(2/6)
TC74VHCT04AFT
INVERTER
7.5
C894
0.47
25V
F:CHIP
TP
TO (2/5)
PSIG
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
HVDD
XRGT
MODE3
MODE2
MODE1
HST
HCK2
HCK1
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
DWN
TO (2/5)
TP FROM (2/5)
C(3/5)
LCD DRIVER,
AUDIO AMP
B-SS1697<08.>-C..-P3
8-17
VPL-CS1
A
B
C
D
8-17
E
F
G
H
4
5
C (4/5)
C (4/5)
• Refer to page 8-14 for Printed Wiring Board
• Refer to page 8-20 for Waveforms
• Refer to page 8-20 for IC Block Diagrams
1
15.5V
15.5V
L809
1µH
C899
0.1
25V
B:CHIP
+15.5V
B-SID IN TO (3/5)
FROM (3/5) B VCOM
SCEN
SCEN
C903
#
1
4
5
6
7
8
9 10 11 12 13 14 15 16
7.0
R968
10k
:CHIP
POS-CON1
POS-CON2
RB DIR
FROM (3/5)
DWN
CN812
24P
WHT
5V-2
VID5
R962
10 :CHIP
24 1
23 2
22 3
21 4
20 5
19 6
18 7
17 8
16 9
15 10
14 11
13 12
12 13
11 14
10 15
9 16
8 17
7 18
6 19
5 20
4 21
3 22
2 23
1 24
VID4
VID3
VID5
VID2
VID6 TP811
VID1
JL861 #
ENB
FRP
PRG
+5V
C931
0.1
25V
B:CHIP
10
JL863
#
DAC
FROM (3/5)
HST
HCK1B
HCK2B
ENB
VCK
VST
PCG
TP
FROM (2/5)
3.4
0.4
TO LCD PANEL(B)
R965
10k
:CHIP
VID6
R966
10 :CHIP
NC
NC
4.4
5.0
SH-OUT6
NC
NC
DIR-CNT
3
ENB
2
5.0
S-12-CNT
NC
NC
C933
0.47
25V
F:CHIP
PSIG
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
HVDD
RGT
MODE3
MODE2
MODE1
HST
HCK1
HCK2
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
NC
6.9
VCOM OFST
2.0
VCOM OUT
6.5
SIG CEN
NC
2.4
SID-OUT
0
ISET
1.3
SID-IN
NC
VCC
3.3
SID-OFST
3.3
2.2
7.0
SH-IN
7.0
FRP
2.5
OFFSET
INV-OUT
VIDEO IN
SH-OUT2
7.0
VDD
NC
CLK-OUT
SH-OUT3
7.0
CLK-OUT
PVCC
IC818
CXA2112R
LCD DRIVER
(R)
NC
NC
NC
NC
DGND
PGND
CLK-IN
NC
3.4
SH-OUT4
7.0
CLK-IN
NC
SH-OUT5
PRG
7.0
NC
NC
NC
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16
POS-CON1
POS-CON2
SH-OUT6
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
7.0
NC
7.0
NC
B-SID OUT FROM (3/5)
VID4
R960
10 :CHIP
NC
3.7
INV-CNT
0
NC
SH-OUT5
PRG
C929
#
C925
0.1
25V
B:CHIP
MCLK
4.4
5.0
NC
C923
47
6.3V
:AL-CP
C921
#
GND2
7.0
NC
7.0
R958
10 :CHIP
C919
0.1
25V
B:CHIP
SH-OUT1
DIR-CNT
SH-OUT4
3.4
3.4
VID3
4.8
MCLK
ENB
NC
3.4
CLK-IN
INV-CON
VID2
R956
10 :CHIP
DLY-CNT
NC
CLK-IN
MCLK
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
R969
10k
:CHIP
RB DIR TO (3/5)
JL860
#
C916
100
16V
:AL-CP
C920
0.1
25V
B:CHIP
VID1
R955
10 :CHIP
VID2
R957
10 :CHIP
VID3
R959
10 :CHIP
C922
#
C930
#
5V-2
VID4
R961
10 :CHIP
VID5
VID6
TO LCD PANEL(R)
R967
10 :CHIP
VID4
VID3
VID5
VID2
VID6
VID1
DWN
TP812
11
BLUE
DAC
FROM (3/5)
TP
TO (2/5)
C932
0.1
25V
B:CHIP
JL864 #
HST
HCK1R
HCK2R
ENB
VCK
VST
PCG
TP
FROM (2/5)
CN813
24P
WHT
R964
10k
:CHIP
R963
10 :CHIP
JL862
#
ENB
PGND
3.7
FROM (2/5)
5.0
NC
DGND
MCLK
R954
10 :CHIP
S-12-CNT
NC
NC
C960
10 10V F:CHIP
NC
IC817
CXA2112R
LCD DRIVER
(B)
NC
VID1
C915
47
R953
25V
0
:AL-CP :CHIP
FB822
BK2125HM601T
NC
PVCC
FB824
BK2125HM601T
DLY-CON
FB820
BK2125HM601T
C912
0.1
25V
B:CHIP
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
NC
7.0
R998
820
:RN-CP
5V-2
C918
0.1
25V
B:CHIP
+15.5V
C910
#
JL858 #
GND
SH-OUT3
CLK-OUT
R999
3k :RN-CP
F/R-CNT
CLK-OUT
SID-OUT
NEXT-IN
NC
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
C917
0.1
25V
B:CHIP
C914
100
16V
:AL-CP
FROM (1/5) R OUT
5.0
0
4.1
NC
6.9
VCOM OFST
2.2
VCOM OUT
6.5
SIG CEN
NC
2.4
SID-OUT
6.9
ISET
1.3
SID-IN
NC
VCC
3.3
SID-OFST
OFFSET
3.3
2.2
7.0
SH-IN
7.0
FRP
2.5
7.0
NC
3.4
0.4
SH-OUT2
VDD
NC
3
NC
3.7
INV-CNT
0
NC
C928
0.1
25V
B:CHIP
MCLK
GND
C926
47
6.3V
:AL-CP
7.0
F/R-CNT
3.4
3.4
GND2
SH-OUT1
NEXT-IN
INV-CON
MCLK
5.0
0
4.1
MCLK
4.8
NEXT-OUT
3.7
DLY-CNT
POS-CNT2
MCLK
FROM (2/5)
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
INV-OUT
C959
10 10V F:CHIP
VIDEO IN
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
POS-CNT1
FB823
BK2125HM601T
DLY-CON
C911
0.1 25V B:CHIP
C907
0.1
25V
B:CHIP
R951
27k
:RN-CP
NEXT-OUT
R996
820
:RN-CP
C908
#
C909
0.1
25V
B:CHIP
POS-CNT2
R997
3k :RN-CP JL857 #
FB821
BK2125HM601T
JL859
#
TP809
POS-CNT1
SID-OUT
C913
47
25V R952
0
:AL-CP :CHIP
C904
10p
CH:CHIP
RINV
9
PRG
C906
0.1
25V
B:CHIP
R950
27k
:RN-CP
FROM (1/5) B OUT
5V-2
FB819
BK2125HM601T
L810
1µH
FRP
C905
10p
CH:CHIP
TP810
L811
1µH
C901
#
C900
0.1
25V
B:CHIP
+15.5V
BINV
8
4
R-SID IN TO (3/5)
FROM (3/5) R VCOM
C902
0.1
25V
B:CHIP
+15.5V
2
C898
47
25V
:AL-CP
FROM (3/5)
C897
47
25V
:AL-CP
R-SID OUT
C896
0.1
25V
B:CHIP
15.5V-4
15.5V-3
L808
1µH
TP
FROM (2/5)
24 1
23 2
22 3
21 4
20 5
19 6
18 7
17 8
16 9
15 10
14 11
13 12
12 13
11 14
10 15
9 16
8 17
7 18
6 19
5 20
4 21
3 22
2 23
1 24
PSIG
SIG4
SIG3
SIG5
SIG2
SIG6
SIG1
HVDD
RGT
MODE3
MODE2
MODE1
HST
HCK1
HCK2
VSS
BLK
ENB
VCK
VST
PCG
DWN
VVDD
COM
RED
C934
0.47
25V
F:CHIP
C(4/5)
LCD DRIVER,
AUDIO AMP
B-SS1697<08.>-C..-P4
5
8-18
A
B
C
D
8-18
VPL-CS1
E
F
G
H
C (5/5)
C (5/5)
• Refer to page 8-14 for Printed Wiring Board
• Refer to page 8-20 for Waveforms
• Refer to page 8-20 for IC Block Diagrams
SPEAKER
SP-R
AUDIO GND
SP-L
AUDIO GND
1
1
2
3
4
CN814
4P
RED
:SMD
GND
C937
220
10
3.5 :AL-CP
VS
2
RF.B. R-OUT
JL866
#
7.6
R971
47k
:CHIP
C935
2.2
20V
:TA
R983
2.2k
:CHIP
12V
C954
0.01
B:CHIP
C946
0.047
B:CHIP
R979
1
:CHIP
C948
0.22
25V
B:CHIP
R985
220
:CHIP
R980
5.6k
:CHIP
0
JL874 R986
0
#
:CHIP
RF.B.R-OUT
4
IN-R
JL865
#
L813
2.2µH
3
5
6
JL868
#
2
R987
#
R988
0
:CHIP
3
4
5
6
7
8
C942
47
16V
:AL-CP
C943
0.1
25V
B:CHIP
C953
0.01
B:CHIP
C951
0.01
B:CHIP
R982
2.2k
:CHIP
3.5
C941
220
10V
:AL-CP
IC819
NJM062M
AUDIO AMP
R984
220
:CHIP
C945
0.047
B:CHIP
0.5
R990 R991
100
100
:CHIP :CHIP
2
0.5
C944
2.2
20V
:TA
9 10
C952
10
20V
:TA-CP
R989
100
:CHIP
R977
47k
:CHIP
R976
8.2k
:CHIP
7.6
VS
1
5.9
5.9
5.9
5.9
5.9
5.9
5.9
0
0
4.0
2.5
1
A-R
C940
1
10V
B:CHIP
20 19 18 17 16 15 14 13 12 11
IC820
CXA1846BN-T4
VOLUME
IN-L L-OUT
GND
0
5.9
5.9
5.9
5.9
5.9
6.0
JL873 R975
0
#
:CHIP
LF.B.
7
0
C938
10
16V
:AL-CP
C939
10
20V
:TA-CP
R974
#
A-L
FROM (1/5)
0
0
R972
0
:CHIP
2
JL867
#
C927
0.1
25V
B:CHIP
FROM (1/5)
AUDIO-MUTE
Q812
Q813 DTC144EKA
DTC144EKA SW
0
SW
8
L812
4.7µH
AUDIO +B
L-OUT
IN-R
1
3
6
IN-L
7
0
AUDIO GND
LF.B.
4
5
0.5
R973
8.2k
:CHIP
8
C936
1
10V
B:CHIP
FROM (1/5)
IC821
NJM062M
AUDIO AMP
R978
1
:CHIP
Q810
2SA1162 R992
1.5k
MUTE
C949
100
16V
:AL-CP
:CHIP
7.6
C950
0.1
25V
B:CHIP
C947
0.22
25V
B:CHIP
R981
5.6k
:CHIP
3
R993
3.3k
:CHIP
Q811
7.5
7.6 2SC2712
APCE
SDAT
A-SCLK
C955
10
16V
:AL-CP
MUTE
R994
100k
:CHIP
AUDIO-MUTE
0
R995
10k
:CHIP
FROM (1/5)
APCE
APCE
A-SCLK
A-SCLK
SDAT
SDAT
C(5/5)
LCD DRIVER,
AUDIO AMP
B-SS1697<08.>-C..-P5
4
5
8-19
VPL-CS1
A
B
C
D
8-19
E
F
G
H
VCOMOUT
35
34
33
S/H
Vcc
CLOCK
DELAY
CLK OUT 54
S/H
S/H
CLK OUT/ 55
S/H
S/H
S/H
31
SH OUT1
NC
29
SH OUT2
28
NC
BUFFER
27
SH OUT3
PVcc
D.P
D.P
PGND
NC
BUFFER
26
25
24
23
22
21
20
NC
BUFFER
D.P 57
S/H
OFFSET CANCEL
DGND 58
S/H
PULSES
2
S/H
10.3 Vp-p
TP809 [RINV]
10.3 Vp-p
TP811 [B-VID|OUT]
CLK IN 59
10.3 Vp-p
TP812 [R-VID|OUT]
S/H
TIMING
GENERATOR
OFFSET CANCEL
NC 60
CLK IN/ 61
S/H
PRG 62
S/H
S/H
S/H
BUFFER
OFFSET CANCEL
OFFSET CANCEL
MODE TIMING
NC 63
NC 64
S/H
S/H
S/H
GND2
30
BUFFER
OFFSET CANCEL
D.P 56
!-
S/H
OFFSET CANCEL
D
BUFFER
LATCH
CONTROL
LATCH
32
11
1dB STEP
VOLUME
VCT
BUFFER
ZC
DET
SHIFT
REGISTER
8dB STEP
VOLUME
+
–
1dB STEP
VOLUME
1
2
3
4
5
6
7
8
9
CLK
10.3 Vp-p
TP810 [BINV]
S/H
VCOM
12
DATA
0
DLY CNT 49
MCLK 50
MCLK/ 51
INV CNT 52
VDD 53
BIAS
13
CE
9
10.3 Vp-p
TP808 [G-VID|OUT]
SID
8dB STEP
VOLUME
14
OUT 2
10.3 Vp-p
TP806 [GINV]
–
+
INVERT
AMP
8
15
VRIN 2
3.1 Vp-p
TP814 [HD]
7
16
VCT 2
6
3.3 Vp-p
TP813 [VD]
17
INAO 2
5
1.3 Vp-p
TP803 [B]
18
INP 2
1.4 Vp-p
TP804 [G]
19
INN 2
1.4 Vp-p
TP805 [R]
20
10
INIT
VCOMOFST
36
VCT
SIGCEN
37
VCC
NC
38
N.C.
ISET
39
GND
SID OUT
40
OUT 1
SID IN
41
VRIN 1
D.P
45 44 43 42
VCT 1
D.P
46
INAO 1
SID OFST
48 47
FRP
SH IN
4
INV OUT
3
VIDEO IN
2
OFFSET
1
CXA1846AN (IC820)
INP 1
CXA2112R-T6 (IC815, 817, 818)
C Board Waveforms
1
C
INN 1
C
SH OUT4
19
SH OUT5
18
NC
17
SH OUT6
15
16
POS CNT2
NEXT OUT
NEXT IN
NC
NC
NC
NC
ENB
DIR CNT
14
D.P
D.P
S/12 CNT
2 3 4 5 6 7 8 9 10 11 12 13
F/R CNT
GND
NC
1
POS CNT1
OFFSET CANCEL
MB88346BPFV-EF (IC813)
3
M52749FP-TP (IC803)
12 BIT SHIFT REGISTER
D0
D1 D2
D3 D4
D5 D6
D7 D8
D9 D10 D11
20
VSS 1
GND
R OSD IN
ADDRESS
DECODER
A03 2
8
12
1 2 3 4
19
18
D0
4
A06
A07
1
D0
D7
8 BIT
LATCH
17
3
GND
5
G OSD IN
9
DI
16
CLAMP
Main Brightness
Retrace Blanking
42
34
30
SUB
CONTRAST
MAIN
CONTRAST
OSD MIX
RETRACE
BLANKING
41 R OUTPUT
CLAMP
SUB
CONTRAST
MAIN
CONTRAST
OSD MIX
AMP
RETRACE
BLANKING
38 G OUTPUT
RETRACE
BLANKING
33 R OUTPUT
8
CLAMP
F/B
GND 10
CLK
AMP
CLAMP
F/B
G INPUT 6
G VCC 12V
5
6
R VCC 12V
A01
D7
8 BIT
LATCH
8 BIT
R-2R
D/A CONVERTER
R INPUT 2
12
A04 3
A05 4
A02
VCC=12V
4
B OSD IN 13
8 BIT
R-2R
D/A CONVERTER
15
B INPUT 11
LD
CLAMP
SUB
CONTRAST
MAIN
CONTRAST
OSD MIX
AMP
B VCC 12V 12
35 Contrast ref.
CLAMP
F/B
GND 16
A08 7
14
Contrast(ABL) IN 17
13
A12
OSD
LEVEL
4bit
Main
CONTRAST
8bit
Sync On
Green
Sep
SOG INPUT 7
A09 8
31 Contrast cont.
DO
B SUB CONT 8bit
G SUB CONT 8bit
R SUB CONT 8bit
SOG Sep OUT 20
19
DAC
VCC 5V
(DIGITAL)
23 SDA
BUS
I/F
22 SCL
24 GND
A10 9
12
A11
11
VCC
21
14
1
25 26 27 28 29
32
Clamp Pulse IN
GND
OSD Blanking
DAC output
for cut-off Adj
GND
36
GND
39
GND
5
VDD 10
A01
A12
8-20
A
B
C
D
8-20
VPL-CS1
E
F
G
H
H
H
1
2
H – B SIDE –
H – A SIDE –
SUFFIX ; -11
SUFFIX ; -11
3
D001
SEC1901C
LAMP-LED
R002
10k
:CHIP
D003
Q001
D004
D002
DTA144EKA SEC1801C
SEC1901C
SW
POWER-SAVE DAN202K
PROTECT
TEMP-LED
D005
DAN202K
PROTECT
D006
DAN202K
PROTECT
D007
DAN202K
PROTECT
CN001
12P
:SMD
R001
10k
:CHIP
R003
1k
:CHIP
TO C BOARD CN5020
JL001 #
S001
S002
S003
LEFT
RIGHT
DOWN
R004
27k
:CHIP
R005
12k
:CHIP
S004
UP
S005
S006
S007
S008
POWER
ENTER
MENU
INPUT
R008
2.7k
:CHIP
R009
2.2k
:CHIP
R010
1.5k
:CHIP
5.0
JL002 #
-1.4
JL003 #
JL004 #
R006
6.8k
:CHIP
R007
3.9k
:CHIP
R011
1.8k
:CHIP
JL005 #
R012
330
:CHIP
JL006 #
JL007 #
JL008 #
JL009 #
S009
APA
R013
2.7k
:CHIP
S010
S011
VOL+
VOL-
R014
2.2k
:CHIP
D009
DAP202K
PROTECT
S012
RESET
R016
1.8k
:CHIP
R015
1.5k
:CHIP
D010
DAP202K
PROTECT
D011
DAP202K
PROTECT
D012
DAP202K
PROTECT
JL010 #
12
11
10
9
8
7
6
5
4
3
2
1
4
GND
D.5V
POWER-LED
TEMP-LED
LANP-LED
PSAVE-LED
LIGHT
SUB 5V
KEY1
KEY0
SIRCS NR
GND
C001
0.1
25V
B:CHIP
D008
SEC2422C
POWER/STBY
H
(CONTROL PANEL)
5
B-SS1697<08.>-H..
8-21
VPL-CS1
A
B
C
D
8-21
E
F
G
H
GA
——
GA
——
1-675-795-11
1
2
3
D601
D602
D603
D604
D605
D606
D607
D608
D609
D610
D611
D612
D613
D614
D615
D616
D617
D618
D619
D620
D621
D622
G-1
D-1
∗ E-1
∗ E-1
E-1
C-3
C-3
C-3
B-3
C-2
C-3
∗ C-2
C-2
C-3
D-3
D-3
D-3
C-3
∗ D-3
C-3
∗ D-3
∗ B-2
IC602
IC603
IC603
IC604
IC604
IC605
IC671
IC671
IC672
∗ A-4
C-2
∗ C-2
D-3
∗ D-3
∗ F-1
∗ A-3
∗ A-4
∗ A-3
Q601
Q601
Q602
Q602
Q603
Q604
E-1
∗ E-1
E-3
∗ F-3
∗ C-3
∗ G-1
VD602
VD604
G
GA
E
F
D
C
B
A
1
2
3
4
GA – B SIDE –
SUFFIX ; -11
E-3
G-1
*:B Side mount
A
C
B
D
E
F
G
1
4
2
3
5
4
GA – A SIDE –
SUFFIX ; -11
8-22
A
B
C
D
8-22
VPL-CS1
E
F
G
H
GA
GA
• Refer to page 8-22 for Printed Wiring Board
CAUTION: For continued protection against risk of
fire, replace only with same type and
rating of fuse.
1
VD602
ERZV14D471
D603
D1FS4A-TA
C638
2.2
450V
D605
TF861S
C608 10
I
D604
D1FS4A-TA
O
R673
390
1/2W
:CHIP
C674
47
16V
IC602
TL431BCDR2
SHUNT REGULATOR
R611
390
1/2W
:CHIP
3
5
2
C671
0.01 :CHIP
R675
47k :CHIP
K
R615
6.8k
:RN-CP
D
C615
0.1
B:CHIP
CN608
#
SUB+5
SUB+5
GND2
GND2
CN605
4P
WHT
TO QA BOARD CN101
A
REF
A
A
A
9
4
4
1
8
D611
P6KE350A
D613
P6KE350A
3
2
A
REF
A
R623
1k
:CHIP
A
A
PH601
PC123FY2
5
4
2
R677
33k
:CHIP
R678
68k
:CHIP
R679
4.7k
:RN-CP
Q671
2SC2712
INVERTER
IC671
TL431BCDR2
SHUNT REGULATOR
8
K
S
R621
6.8
:CHIP
C617
47
25V
C672
10
R654
4.7k
:CHIP
6
C
R625
270k
1/2W
:CHIP
C635
0.01
:CHIP
7
IC603
TOP222Y-BB
PWM CONTROL
D612
C616
RD8.2M-T1B1
#
R620
220
:CHIP
PS601
2A
1
R613
4.7
:FPRD
GND 1 B
R618
4.7k
:RN-CP
5
C612
220
25V
C611
470
25V
R672
R671
10
15k
:RN-CP :CHIP
R676
6.8k
:RN-CP
+5V
3
1
6
R674
180
1/2W
:CHIP
8
D609
D10SC9M
7
1
CN607
#
C675 #
R608
10k
1/4W
:FPRD
T601
SRT
D610
RGP10G
DC W
1
2
3
4
G
C673
0.1
B:CHIP
D606
RD20ES-T1B2
R607
100k
:CHIP
D608
RGP10J600V,1A
C609
100p
1kV
R603
15k
:CHIP
1
IC672
BA05FP-E2
S
3
R617
270k
1/2W
D622 :CHIP
RD24M
R610
68k
2W
C610
0.033
630V
R602
12
:CHIP
R606
470
1/2W
:FPRD
D607
P6KE200A
R609
4.7
:FPRD
R605
0.22
5W
:RW
6
Q602
2SD2144S-TP-V
INVERTER
1
C604
220
450V
7
R604
5.6
5W
CN602
#
GND
D602
FSF10A60
600V,10A
C606
#
C603
2200p
:E
C637
0.47
L601
275V SS28V-25045
:MPS
3A
Q601
2SK3013F
600V 16A
1
2
VD604
ZP2600
600V
L602
0µH 5A
2
R601
560k
1/2W
L604
68µH
4
FH601
FH602
D601
D6SB80
800V,6A
2
F601
250V
6.3A
AC IN
100V-120V
220V-240V
50/60Hz
C601
0.0022
:E
C602
0.22
275V
:MPS
3
3
2
1
4
AC(N)
N.C
AC(L)
1
CN601
3P
:VH-B
R622 C636
180
10
1/2W
:CHIP
CN604
6P
WHT
TO GBA BOARD CN671
R626
12k
:CHIP
4
1
3
2
R627
100
:CHIP
R630
47k
3W
:RS
R628
39k
:CHIP
PH602
PC123FY2
C619
0.022 D614
400V P6KE300A
C618
0.1
B:CHIP
+6V
Q603
2SC2712
MAIN CONV ON/OFF
R629
47k
3W
:RS
T602
SRT
D615
FCQ20A06
L603 68µH
12
C621
0.1
B:CHIP
C
D
S
C624
0.1
D619
RD8.2M-T1B1
FA5331M-TE1 (IC605)
2
11
3
10
4
9
5
8
6
7
C620
2700
10V
D618
P6KE350A
R631
6.8
:CHIP
C623
47
16V
D616
FMG-G2CS
1000V,3A
IC604
TOP223Y-BB
PWM CONTROL
C622
#
D620
B:CHIP
P6KE350A
POWER CONT
GND 2
FAN PROT
GND 2
18V
GND
1
2
3
4
5
6
7
8
9
10
T-OUT12
T-OUT12
T-OUT11
6V
6V
GND 2
GND 2
GND 2
GND 2
18V
4
3
TO GBB BOARD CN702
D617
FCQ20A06
CN606
10P
D621
D1FL20U-TA
4
1
R633
220
:CHIP
3
SYNC
CT
CS
REF
VCC
NC
14
15
11
13
10
12
2
PH603
PC123FY2
10µA
R632
1k
:CHIP
C634
1000p
B:CHIP
ON/OFF
BIAS
OSC
1
2
3
4
5
6
9 YC
BIAS
UVLO
Dmax
R635
1.5k
:CHIP
8 OUT
5V
R640
2.2k
:RN-CP
15K
7 GND
PWM COMP
CURR AMP
15K
R643
270k
1/2W
:CHIP
ER.AMP
10K
R636
33k
:CHIP
R641
1.5k
:RN-CP
R645
270k
1/2W
:CHIP
R648
12k
:CHIP
Vr
5 VFB
R649
100
:CHIP
Q
OVP
OCP
4 OVP
Vp
V???
16
1
2
3
IDET
IFB
I IN-
VDET
R652
39k
:CHIP
C633
470p
CH:CHIP
R638
10k
:CHIP
C632
0.15
16V
B:CHIP
IC605
FA5331M-TE1
PFC
R642
180k
1/2W
:CHIP
8
7
6
5
4
3
C631
68p
CH:CHIP
2
R639
2.2k
:RN-CP
1
OUT GND VIN VFB OVP VDET IIN IFB
C628
0.1
F:CHIP
6 VIN
MUL
R
S
S
R637
150k
:CHIP
R634
120
:RN-CP
C629
47
25V
VC VCC
9
R646
180k
1/2W
:CHIP
10
R650
15
:CHIP
11
12
C627
0.15
16V
B:CHIP
C626
330p
B:CHIP
R653
4.7k
:CHIP
R644
220k
1/2W
:CHIP
ON
CS OFF REF SYNC CT IDET
13
14
15
5
16
R647
180k
1/2W
:CHIP
R651
33k
:RN-CP
C625
0.1
B:CHIP
GA
Q604
2SC2712
ACT FILT ON/OFF
ACTIVE FILTER,CONTROL ACTIVE FILTER
MAIN CONVERTER,SUB CONVERTER
B-SS1697<08.>-GA.
8-23
VPL-CS1
A
B
C
D
8-23
E
F
G
H
GBA, GBB
GBA, GBB
1
CN671
6P
WHT
TO GA BOARD CN604
POWER CONT
GND 2
FAN PROT
GND 2
18V
GND 2
1
2
3
4
5
6
R689
22k
:CHIP
CN675
3P
WHT
GBA – B SIDE –
FAN+B
FAN PROT
GND 2
SUFFIX ; -11
Q673
2SC2712
FAN PROTECT
R694
22k
:CHIP
CN674
5P
WHT
R688
10k
:CHIP
C676
100
16V
TO C BOARD CN807
1
2
3
4
5
R687
12k
:CHIP
D672
DAN202K-T-146
FAN2
2
R681
100
:CHIP
Q672
2SC2712
FAN PROTECT
R686
47k
:CHIP
C677
0.1
B:CHIP
1
2
3
R680
1k
R683
100 :CHIP
:CHIP
R682
10k
:CHIP
POWER CONT
FAN PROT
FAN CONT1
FAN CONT2
GND 2
FAN+B 1
FAN PROT 2
GND 2 3
FAN1
CN676
3P
BLK
+18V
R696
27k
:RN-CP
3
VC
6
GND BIAS
5
8
2
BST
FB
4
1
GBA – A SIDE –
VIN VSW
7
C678
0.1
B:CHIP
SUFFIX ; -11
IC673
LT1374IS8#TR
DC-DC CONVERTER
C680
0.1
B:CHIP
C679
22
35V
IC704
PQ20VZ1U
FAN +B2 REG
D673
D1FS4A-TA
C681
270
25V
L671
10µH
R697
82k
:RN-CP
R698
18k
:RN-CP
R699
3
68k
D675
D1FS4A-TA :RN-CP
C683
0.1
B:CHIP
ON/OFF ADJ
O
I
D674
D1FS4A-TA
C684
47
16V
C682
0.1
B:CHIP
R700
0
:CHIP
R701
4.7k
:RN-CP
R716
5.6k R717
:RN-CP 5.6k
:RN-CP
G
R720
10k
:RN-CP
R721
10k
:RN-CP
R718
1k
:RN-CP
C719
33
25V
C718
0.1
B:CHIP
GBA
R719
1k
:RN-CP
FAN DRIVE
DC-DC CONVERTER
B-SS1697<08.>-GBA
CN706
8P
WHT
Q710
2SC2873Y C778
100
SOFT START 16V
D736
RD13ES-T1TB2
R784
82
1/2W
:CHIP
4
R785
1.2k
1/2W
:CHIP
GBB – B SIDE –
R787
1.2k
1/2W
:CHIP
IC701
PQ20VZ1U
16.5V REG.
SUFFIX ; -11
R708
#
C777
47
16V
R781
6.8k
:RN-CP
R788 R789
1.2k 1.2k
1/2W 1/2W
:CHIP :CHIP
R782
10k
:RN-CP
TO GA BOARD CN606
T-OUT12 1
T-OUT12 2
T-OUT11 3
4
6V
5
6V
6
GND 2
7
GND 2
8
GND 2
9
GND 2
10
18V
5
L702
100µH
D728
D2FS6-TA D727
D2FS6-TA
D715
D10SC9M
L707
10µH
C776
47
16V
C740
330
35V
R775
#
GBB – A SIDE –
C769
#
1
2
3
4
5
6
7
8
9
CN707
9P
WHT
R707
15k
:RN-CP
C702
33
25V
C742
470
25V
TO QA BOARD CN102
16.5V
AUDIO+B
GND 2
GND 2
+6V
+6V
GND 2
GND 2
GND 2
O
G
C701
0.1
B:CHIP
L703 150µH
TO C BOARD CN802
AUDIO+B
AUDIO+B
AUDIO GND
AUDIO GND
+16.5V
+16.5V
GND 2
GND 2
ON/OFF ADJ
I
CN702
10P
1
2
3
4
5
6
7
8
R706
1.2k
:RN-CP
R776 C772
#
#
GBB
(DC/DC CONVERTER)
SUFFIX ; -11
B-SS1697<08.>-GBB
8-24
A
B
C
D
8-24
VPL-CS1
E
F
G
H
The material contained in this manual consists of
information that is the property of Sony Corporation.
Sony Corporation expressly prohibits the duplication of
any portion of this manual or the use thereof for any
purpose other than the operation or maintenance of the
equipment described in this manual without the express
written permission of Sony Corporation.
Le matériel contenu dans ce manuel consiste en
informations qui sont la propriété de Sony Corporation.
Sony Corporation interdit formellement la copie de
quelque partie que ce soit de ce manuel ou son emploi
pour tout autre but que des opérations ou entretiens de
l’équipement à moins d’une permission écrite de Sony
Corporation.
Das in dieser Anleitung enthaltene Material besteht aus
Informationen, die Eigentum der Sony Corporation sind.
Die Sony Corporation untersagt ausdrücklich die
Vervielfältigung jeglicher Teile dieser Anleitung oder den
Gebrauch derselben für irgendeinen anderen Zweck als
die Bedienung oder Wartung der in dieser Anleitung
beschriebenen
Ausrüstung
ohne
ausdrückliche
schriftliche Erlaubnis der Sony Corporation.
English
Sony Corporation
9-929-671-01
B & P Company
99KZ08111-1
Printed in Japan
©1999.11