Download Alinco DJ-V57 Service Manual

Service Manual
DJ-V57
Specifications
Circuit Description
Parts List
PC Board View
Adjustment
Schematic Diagram
Block Diagram
Exploded View
ALINCO, INC.
www.ALINCO.ru
SPECIFICATIONS DJ-V57
<GRNERAL>
TX Frequency range
RX Frequency range
Mode
Channel steps
Memory channels
Antenna connector
Frequency stability
Microphone impedance
Power supply
Usable temperature range
<TRANSMITTER>
VHF Output power
136.000～173.995MHz *144.000～145.995MHz
400.000～479.995MHz *430.000～439.995MHz
136.000～173.995MHz
400.000～511.995MHz
F3E(FM)
5、10、12.5、15、20、25 & 30kHz
200 channels, 2 CALL channel
50Ω(unbalanced)
±2.5ppm
2k ohm nominal
7.2V (Ni-MH battery)
7 ～ 16V (external DC IN)
-10℃～+60℃ (external DC IN)
+14°F～+140°F (external DC IN)
*Guaranteed range per specifications
Modulation system
WFM Max. frequency deviation
NFM Max. frequency deviation
Spurious emission
approx. 5W
approx. 4.5W (with battery)
approx. 5W (external DC IN)
Variable reactance frequency modulation
±5kHz
±2.5kHz
-60dB or less
<RECEIVER>
Receive system
Intermediate frequencies
VHF Sensitivity (12dB SINAD)
UHF Sensitivity (12dB SINAD)
Selectivity
Audio output power
Double conversion superheterodyne
38.85MHz(1st) / 450kHz (2nd)
-14dBu (center range)
-12dBu (center range)
-6dB: 12kHz or more / -60dB: 35kHz or less
500mW (at 8ohm, MAX)
UHF Output power
DJ-V57 CIRCUIT DESCRIPTION
[Reception]
1. RX Method: Double Conversion Super Heterodyne
1st IF: 38.85 MHz
2nd IF: 450 KHz
2. Front End
[VHF]
The signal input from antenna passes through the low pass filter, and then it is
amplified at RF amplifier Q117. The amplified signal is led to band pass filter
and band switch D132, then input to the mixer Q120.
[UHF]
The signal input from antenna passes through the high pass filter and low pass
filter, and then it is amplified at RF amplifier Q123. The amplified signal is led
to band pass filter and band switch D132, then input to the mixer Q120.
3. Mixer
The input signal to the mixer Q120 and the 1st local signal are added or
subtracted at the mixer Q120, and the crystal filter XF101 selects the signal of
38.85 MHz, then it is amplified at the 1st IF amplifier Q121 after the adjacent
signal is eliminated. The 1st local signal from VCO output is supplied to the
base of mixer Q120 passing through the buffer amplifier Q116.
4. IF
The signal amplified at the 1st IF amplifier Q121 is supplied to pin 16 of IC105
for demodulation. Also the signal of 12.8 MHz from X101 multiplied by three at
Q115, and then it is led to pin 1 of IC105. Two input signals are mixed in the
mixer circuit inside of IC105 and converted into the 2nd IF signal of 450 kHz.
The 2nd IF signal output from pin 3 of IC105 is supplied to pin 5 of IC105 after
eliminating the adjacent signal at the ceramic filter CF101 in WFM mode, or at
the ceramic filter CF102 in NFM mode. The input 2nd IF signal to pin 5 of
IC105 is demodulated at the limiter amplifier and quadrature detection circuit
inside of IC105, then output from pin 9 of IC105 as an AF signal.
5. Squelch
The AF signal from pin 9 of IC105 is input to pin 8 of IC105. The input signal
is output from pin 14 of IC105 passing through the noise filter amplifier and
rectifier circuits inside of IC105. The rectified signal is input to the A/D port
pin 82 of microcomputer IC109. Judging the signal, the microcomputer controls
ON/OFF of the audio output.
6. Audio
The AF signal from pin 9 of IC105 is amplified at Q119, and then it is input to
pin 6 of IC106 passing through the active high pass filter Q118. The volume of
audio signal is adjusted at the D/A converter IC106. The audio signal is input
to pin 2 of audio power amplifier IC104 and output from pin 6 to drive a
speaker.
7. VCO
[VHF]
VCO in VHF band consists of the Colpitts oscillator. D106, D112, L112 and
L115 determine the oscillating frequency, and the signal is oscillated at the
transistor Q103. L115 is passed at shift transistor Q107 when transmitting.
The oscillated signal is supplied to pin 16 of PLL-IC102 passing through the
buffer amplifier Q114.
[UHF]
VCO in VHF band consists of the Colpitts oscillator. D119, D124, L127 and
L129 determine the oscillating frequency, and the signal is oscillated at the
transistor Q108. L129 is passed at shift transistor Q111 when transmitting.
The oscillated signal is supplied to pin 16 of PLL-IC102 passing through the
buffer amplifier Q114.
8. PLL
PLL-IC102 is used to control the oscillating frequency of VCO. IC102 is
controlled by the serial control signal sent from the microcomputer IC109. The
12.8MHz for reference frequency of IC102 oscillates in the TCXO X101.
IC102 compares the frequency gained by dividing the signal input to pin 16 of
IC102 by the control signal from IC109 with the frequency gained by dividing
the reference frequency of 12.8 MHz. When the phase difference is found as a
result of phase comparison, the pulse signal is output from the charge pump
output of pin 21 of IC102, then the signal is converted into the DC voltage at
the low pass filter and added to the cathode side of VCO vari-cap to make the
phases equal. In result the stabilized oscillation can be done at the desired
frequency.
[Transmission]
1. Microphone Amplifier
The microphone amplifier IC110 has four operational amplifiers. The voice is
converted into the electric signal through the microphone, and then supplied to
IC110. The input signal is amplified and pre-emphasized to be output.
The signal output from microphone amplifier is adjusted the maximum
frequency deviation at D/A converter IC106. The adjusted signal is added to
the cathode of D111 of VHF or D123 of UHF VCO for deviation to change the
capacity of the oscillation circuit resulting the FM deviation.
2. Power Amplifier
The oscillated signal at VCO is amplified at pre-driver amplifier IC101, driver
amplifier Q105 and power amplifier Q101. The power-amplified signal is
supplied to the antenna through the duplexer after the harmonics are rejected
enough at the low pass filter.
Parts List DJ-V57
MAIN Unit
Ref.No.
Parts No.
C101
CU3559
C102
CU3535
C103
CU3523
C104
CU3535
C105
CU3554
C106
CU3535
C107
CU3535
C108
CU0124
C109
CU3504
C110
CU3513
C111
CU3535
C112
CU3515
C113
CU3511
C114
CU3514
C115
CU3559
C116
NC
C117
CU3517
C118
CU3516
C119
NC
C120
CU3513
C121
CU3516
C122
CU3515
C123
CU3502
C124
CU3502
C125
CU3518
C126
CU3518
C127
CU3017
C128
NC
C129
NC
C130
CU3535
C131
CU3502
C132
CU3501
C133
CU3535
C134
CU3514
C135
CU3513
C136
CU3511
C137
CU3547
C138
CU3535
C139
CU3527
C140
CU3535
C141
CU3502
C142
CU3502
C143
CU3502
C144
CU3547
C145
CU3514
C146
CU3535
C147
CU3148
C148
CU3547
C149
CU3535
C150
CU3527
C151
CU3515
C152
CU3527
C153
CU3535
C154
CU3535
C155
CU3535
C156
CU0119
C157
CU3547
C158
CU3535
C159
CU3535
Parts Name
GRM155B30J105KE18D
GRM155B11H102KA01D
GRM1552C1H101JZ01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM21BB30J226ME38L
GRM1553C1H3R0CZ01D
GRM1552C1H150JZ01D
GRM155B11H102KA01D
GRM1552C1H220JZ01D
GRM1552C1H100JZ01D
GRM1552C1H180JZ01D
GRM155B30J105KE18D
GRM1552C1H330JZ01D
GRM1552C1H270JZ01D
GRM1552C1H150JZ01D
GRM1552C1H270JZ01D
GRM1552C1H220JZ01D
GRM1554C1H1R0CZ01D
GRM1554C1H1R0CZ01D
GRM1552C1H390JZ01D
GRM1552C1H390JZ01D
C1608CH1H330JT-NS
GRM155B11H102KA01D
GRM1554C1H1R0CZ01D
GRM1554C1HR50CZ01D
GRM155B11H102KA01D
GRM1552C1H180JZ01D
GRM1552C1H150JZ01D
GRM1552C1H100JZ01D
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM1552C1E221JA01D
GRM155B11H102KA01D
GRM1554C1H1R0CZ01D
GRM1554C1H1R0CZ01D
GRM1554C1H1R0CZ01D
GRM155B11C103KA01D
GRM1552C1H180JZ01D
GRM155B11H102KA01D
GRM188B31E105KA75D
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM1552C1E221JA01D
GRM1552C1H220JZ01D
GRM1552C1E221JA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM21BB30J106KE18L
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
1
C160
C161
C162
C163
C164
C165
C166
C167
C168
C169
C170
C171
C172
C173
C174
C175
C176
C177
C178
C179
C180
C181
C182
C183
C184
C185
C186
C187
C188
C189
C190
C191
C192
C193
C194
C195
C196
C197
C198
C199
C200
C201
C202
C203
C204
C205
C206
C207
C208
C209
C210
C211
C212
C213
C214
C215
C216
C217
C218
C219
C220
C221
CU3547
CU3535
CU3535
CS0396
CU3527
CU3535
CU3531
CU3508
CU3523
CU3554
CU3554
CU3535
CU3009
CU3007
CU3013
NC
CU3531
CU3507
CU3509
CU3535
CU3143
CU3554
CU3531
CU3518
CU3507
CU3502
CU3511
CU3512
CU3501
CU3531
CU3507
CU3506
CU3518
CU3535
CU3554
CU3501
CU3535
CU3507
CU3501
CU3501
CU3535
CS0396
CU3523
CU3523
CU3502
CU3535
CU3511
CU3556
CU3531
CS0397
CU3506
CU3535
CU3535
CU3531
CS0396
CU3554
CU3535
CU3507
CU3523
CU3535
CU3507
NC
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
TMCP1D104MTRF
GRM1552C1E221JA01D
GRM155B11H102KA01D
GRM155B11H471KA01D
GRM1552C1H7R0DZ01D
GRM1552C1H101JZ01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
C1608CH1H080DT-NS
C1608CH1H060DT/S
C1608CH1H150JT/S
GRM155B11H471KA01D
GRM1552C1H6R0DZ01D
GRM1552C1H8R0DZ01D
GRM155B11H102KA01D
GRM188B30J475KE18D
GRM155B11A104KA01D
GRM155B11H471KA01D
GRM1552C1H390JZ01D
GRM1552C1H6R0DZ01D
GRM1554C1H1R0CZ01D
GRM1552C1H100JZ01D
GRM1552C1H120JZ01D
GRM1554C1HR50CZ01D
GRM155B11H471KA01D
GRM1552C1H6R0DZ01D
GRM1552C1H5R0CZ01D
GRM1552C1H390JZ01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM1554C1HR50CZ01D
GRM155B11H102KA01D
GRM1552C1H6R0DZ01D
GRM1554C1HR50CZ01D
GRM1554C1HR50CZ01D
GRM155B11H102KA01D
TMCP1D104MTRF
GRM1552C1H101JZ01D
GRM1552C1H101JZ01D
GRM1554C1H1R0CZ01D
GRM155B11H102KA01D
GRM1552C1H100JZ01D
GRM155B10J224KE01E
GRM155B11H471KA01D
TMCP1C105MTRF
GRM1552C1H5R0CZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H471KA01D
TMCP1D104MTRF
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM1552C1H6R0DZ01D
GRM1552C1H101JZ01D
GRM155B11H102KA01D
GRM1552C1H6R0DZ01D
2
C222
C223
C224
C225
C226
C227
C228
C229
C230
C231
C232
C233
C234
C235
C236
C237
C238
C239
C240
C241
C242
C243
C244
C245
C246
C247
C248
C249
C250
C251
C252
C253
C255
C256
C257
C258
C260
C261
C262
C263
C264
C265
C266
C267
C268
C269
C270
C271
C272
C273
C274
C275
C276
C277
C278
C279
C280
C281
C282
C283
C284
C285
CU3547
CU3508
CU3521
CU3535
CU3575
CU3503
CU3502
CU3502
CU3511
CU3521
NC
CU3521
NC
CU3517
CU3505
CU3535
NC
CU3535
CU3547
CU3535
NC
CU3519
CU3535
CU3523
CU3523
CU3523
CU3547
CU3517
CU3535
CU3535
CU3554
CU3554
CU3539
CU3539
CU3547
CU3554
CU3547
CU3547
CU3547
CU3535
CU3517
CU3547
CU3148
CU3554
CU3523
CU3501
CU3501
CU3575
CE0463
CU3507
CU3547
NC
CU3503
CU3502
CU3535
NC
CU3509
CU3575
CU3523
CU3535
CU3547
CU3547
GRM155B11C103KA01D
GRM1552C1H7R0DZ01D
GRM1552C1H680JZ01D
GRM155B11H102KA01D
GRM1554C1H1R5BZ01D
GRM1554C1H2R0CZ01D
GRM1554C1H1R0CZ01D
GRM1554C1H1R0CZ01D
GRM1552C1H100JZ01D
GRM1552C1H680JZ01D
GRM1552C1H680JZ01D
GRM1552C1H330JZ01D
GRM1552C1H4R0CZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM1552C1H470JZ01D
GRM155B11H102KA01D
GRM1552C1H101JZ01D
GRM1552C1H101JZ01D
GRM1552C1H101JZ01D
GRM155B11C103KA01D
GRM1552C1H330JZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM155B11H222KA01D
GRM155B11H222KA01D
GRM155B11C103KA01D
GRM155B11A104KA01D
GRM155B11C103KA01D
GRM155B11C103KA01D
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM1552C1H330JZ01D
GRM155B11C103KA01D
GRM188B31E105KA75D
GRM155B11A104KA01D
GRM1552C1H101JZ01D
GRM1554C1HR50CZ01D
GRM1554C1HR50CZ01D
GRM1554C1H1R5BZ01D
10CE100BSS
GRM1552C1H6R0DZ01D
GRM155B11C103KA01D
GRM1554C1H2R0CZ01D
GRM1554C1H1R0CZ01D
GRM155B11H102KA01D
GRM1552C1H8R0DZ01D
GRM1554C1H1R5BZ01D
GRM1552C1H101JZ01D
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11C103KA01D
3
C286
C287
C288
C289
C290
C291
C292
C293
C294
C295
C296
C297
C298
C299
C300
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C339
C340
C341
C342
C343
C344
C345
C346
C347
C348
C349
CU3535
CU3535
NC
CU3531
CU3554
CU3554
NC
CU3519
CS0397
CU3531
CU3510
CU3509
CU3509
CU3509
CE0436
CU3535
CU3535
CU3535
CU3531
CU3527
CU3554
CU0124
CU3547
CU3535
CU3531
CU3554
CU3554
CU3554
CU3527
CU3535
CU3535
CU3535
CU3138
CU3554
CU3554
CU3535
CU3554
CU3535
CU3535
CU3554
CU3554
CU0124
CU3138
CU3535
CS0439
CU3535
CU3535
CU3535
CU3554
CU3559
CU3535
CU3535
CU0119
CU3535
CU3547
CU3547
CU3559
CU3138
CU3148
CU3535
CU3554
CU3148
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H471KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM1552C1H470JZ01D
TMCP1C105MTRF
GRM155B11H471KA01D
GRM1552C1H9R0DZ01D
GRM1552C1H8R0DZ01D
GRM1552C1H8R0DZ01D
GRM1552C1H8R0DZ01D
16CE47BSS
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H471KA01D
GRM1552C1E221JA01D
GRM155B11A104KA01D
GRM21BB30J226ME38L
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM155B11H471KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM1552C1E221JA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM188B31C225KE14D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11A104KA01D
GRM21BB30J226ME38L
GRM188B31C225KE14D
GRM155B11H102KA01D
TMCMA0J476MTRF
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B30J105KE18D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM21BB30J106KE18L
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11C103KA01D
GRM155B30J105KE18D
GRM188B31C225KE14D
GRM188B31E105KA75D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM188B31E105KA75D
4
C350
C351
C352
C353
C354
C355
C356
C357
C358
C359
C360
C361
C362
C363
C364
C365
C366
C367
C368
C369
C370
C371
C372
C373
C374
C375
C376
C377
C378
C379
C380
C381
C382
C383
C384
C385
C386
C387
C388
C389
C390
C391
C392
C393
C394
C395
C396
C397
C398
C399
C400
C401
C402
C403
C404
C405
C406
C407
C408
C409
C410
C411
CU3535
CU3535
CU3554
CU0119
CU3535
CU0119
CU3535
CU3547
NC
CU3553
CU3553
CU3527
CU3545
CU3554
CU3559
CU3523
CU3539
CU3554
CU3535
CS0439
NC
CU3514
CU3535
CU3541
CU3554
CU3547
CU3148
CU3535
CU3513
CU3535
CU3553
CU3543
CU3535
CU3148
CU3535
CU3554
CU3533
CU3523
CU3535
CU3559
CU3148
CU3535
CU3559
CU3554
CU3541
CU3535
CU0119
CU3535
CU3535
CU3535
CU3553
CU3559
NC
CU3535
CU3547
CU3535
CU3527
CU3535
CE0436
CU3535
CU3547
CU3547
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM21BB30J106KE18L
GRM155B11H102KA01D
GRM21BB30J106KE18L
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11A473KA01D
GRM155B11A473KA01D
GRM1552C1E221JA01D
GRM155B11E682KA01D
GRM155B11A104KA01D
GRM155B30J105KE18D
GRM1552C1H101JZ01D
GRM155B11H222KA01D
GRM155B11A104KA01D
GRM155B11H102KA01D
TMCMA0J476MTRF
GRM1552C1H180JZ01D
GRM155B11H102KA01D
GRM155B11H332KA01D
GRM155B11A104KA01D
GRM155B11C103KA01D
GRM188B31E105KA75D
GRM155B11H102KA01D
GRM1552C1H150JZ01D
GRM155B11H102KA01D
GRM155B11A473KA01D
GRM155B11E472KA01D
GRM155B11H102KA01D
GRM188B31E105KA75D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM155B11H681KA01D
GRM1552C1H101JZ01D
GRM155B11H102KA01D
GRM155B30J105KE18D
GRM188B31E105KA75D
GRM155B11H102KA01D
GRM155B30J105KE18D
GRM155B11A104KA01D
GRM155B11H332KA01D
GRM155B11H102KA01D
GRM21BB30J106KE18L
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM155B11A473KA01D
GRM155B30J105KE18D
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11H102KA01D
GRM1552C1E221JA01D
GRM155B11H102KA01D
16CE47BSS
GRM155B11H102KA01D
GRM155B11C103KA01D
GRM155B11C103KA01D
5
C412
C414
C415
C416
C417
C418
C419
C421
C422
C423
C424
C425
C426
C427
C428
C429
CF101
CF102
D101
D102
D103
D104
D106
D107
D108
D109
D110
D111
D112
D113
D114
D116
D117
D118
D119
D120
D121
D122
D123
D124
D125
D126
D127
D128
D129
D130
D131
D132
D133
D134
D135
D136
D137
D138
D139
D140
D141
D142
D143
D144
D145
D146
CU3554
CU3523
CU3535
CU3554
CU0119
CU3554
CU3535
NC
CU3507
CU3508
CU3507
CU3535
NC
NC
CU3535
CU3143
XC0075
XC0074
XD0419
XD0326
XD0422
XD0339
XD0421
XD0422
XD0433
XD0422
XD0422
XD0422
XD0421
XD0451
XD0326
XD0503
XD0339
XD0503
XD0454
XD0497
XD0433
XD0422
XD0422
XD0454
XD0339
XD0339
XD0498
XD0339
XD0421
XD0421
XD0421
XD0497
XD0486
XD0486
XD0486
XD0486
XD0497
XD0497
XL0097
XL0128
XL0128
XD0418
XD0424
XD0338
XL0128
XL0128
GRM155B11A104KA01D
GRM1552C1H101JZ01D
GRM155B11H102KA01D
GRM155B11A104KA01D
GRM21BB30J106KE18L
GRM155B11A104KA01D
GRM155B11H102KA01D
GRM1552C1H6R0DZ01D
GRM1552C1H7R0DZ01D
GRM1552C1H6R0DZ01D
GRM155B11H102KA01D
GRM155B11H102KA01D
GRM188B30J475KE18D
CFUKG450KE4A-R0
CFUKG450KG1A-R0
1SS400 TE61
1SV307(TPH3,F)
HSC277TRF-E
1SV308(TPH3,F)
1SV323(TPH3,F)
HSC277TRF-E
RB715WTL
HSC277TRF-E
HSC277TRF-E
HSC277TRF-E
1SV323(TPH3,F)
015AZ3.0-X(TPL3,F)
1SV307(TPH3,F)
JDP2S04E(TPH3,F)
1SV308(TPH3,F)
JDP2S04E(TPH3,F)
1SV305(TPH3,F)
1SS364(TE85L,F)
RB715WTL
HSC277TRF-E
HSC277TRF-E
1SV305(TPH3,F)
1SV308(TPH3,F)
1SV308(TPH3,F)
1SV329(TPH3,F)
1SV308(TPH3,F)
1SV323(TPH3,F)
1SV323(TPH3,F)
1SV323(TPH3,F)
1SS364(TE85L,F)
1SV331(TPH3,F)
1SV331(TPH3,F)
1SV331(TPH3,F)
1SV331(TPH3,F)
1SS364(TE85L,F)
1SS364(TE85L,F)
SML-521MUWT86
SML-D12M8WT86
SML-D12M8WT86
RB521S-30TE61
S3JB-T
1SS362(TE85L,F)
SML-D12M8WT86
SML-D12M8WT86
6
D147
D148
D149
D150
D151
D152
D153
D154
D155
D156
FB101
FB102
FB103
FB104
FB106
IC101
IC102
IC103
IC104
IC105
IC106
IC107
IC108
IC109
IC110
IC111
IC112
IC113
IC114
JK101
JK102
L101
L102
L103
L104
L105
L106
L107
L108
L109
L110
L111
L112
L113
L114
L115
L116
L117
L119
L120
L121
L122
L123
L124
L125
L126
L127
L129
L130
L132
L133
L134
XD0419
XD0338
XL0128
XL0128
XD0418
XD0499
XD0418
XD0499
XD0338
XD0503
QB0057
QB0057
QB0057
QB0057
QB0065
XA0968
XA1410
XA1103
XA0210
XA1391
XA1411
XA0617
XA1119
XA1496
XA1106
XA1103
XA1106
XA1120
XA1413
UJ0060
UJ0061
QS402006
QS401405
QS402006
QS401405
QS501403
QC0812
QC0762
QC0762
QC0779
QS402006
QC0902
QC0956
QS402006
QC0812
QC0786
QC0736
QC0816
QS401405
QS401405
QS401205
QS501402
QC0808
QS401405
QC0773
QS401405
QC0778
QC0774
QC0812
QC0816
QC0816
QC0875
1SS400 TE61
1SS362(TE85L,F)
SML-D12M8WT86
SML-D12M8WT86
RB521S-30TE61
CMS01(TE12L,Q)
RB521S-30TE61
CMS01(TE12L,Q)
1SS362(TE85L,F)
JDP2S04E(TPH3,F)
MPZ1608S101AT/A
MPZ1608S101AT/A
MPZ1608S101AT/A
MPZ1608S101AT/A
FBMH1608HM151-T
UPC2710TB-E3
AK1542-L
LM2904PWR-JF (G4)
NJM2070M-TE1-#ZMZB
NJM2591V-TE1
R2A20178NP#W0
TC75S56FU(TE85L,F)
XC6202P502MR
R5F2L3ACANFP#U1
LM2902PWR (G4)
LM2904PWR-JF (G4)
LM2902PWR (G4)
S-80845CLNB-B66T2G
R1EX24064ATAS0A#S0
HSJ1594-010150
LD-0208-1.3
0.40-2.0-6TLﾃｰﾋﾟﾝｸﾞ
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
0.40-2.0-6TLﾃｰﾋﾟﾝｸﾞ
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
0.50-1.4-3TL ﾃｰﾋﾟﾝｸﾞ
MLG1005SR10J-T/A
C1608CB-56NJ
C1608CB-56NJ
C1608H-10NJ
0.40-2.0-6TLﾃｰﾋﾟﾝｸﾞ
C2012C1R0J
C1608CB-62NG
0.40-2.0-6TLﾃｰﾋﾟﾝｸﾞ
MLG1005SR10J-T/A
C1608H-39NJ
LK10052R2K-T
MLG1005SR22J-T/A
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
E2-0.40-1.2-5TR
0.50-1.4-2TLﾃｰﾋﾟﾝｸﾞ
MLG1005S47NJ-T/A
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
C1608CB-R47J
0.40-1.4-5TLﾃｰﾋﾟﾝｸﾞ
C1608H-8N2J
C1608H-2N7K
MLG1005SR10J-T/A
MLG1005SR22J-T/A
MLG1005SR22J-T/A
C2012H68NH
7
L135
L136
L137
L138
L139
L140
L141
L142
L143
L144
L145
L146
L147
L148
LCD101
MIC101
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q108
Q109
Q110
Q111
Q112
Q113
Q114
Q115
Q116
Q117
Q118
Q119
Q120
Q121
Q122
Q123
Q124
Q125
Q126
Q127
Q128
Q129
Q130
Q131
Q132
Q133
Q134
Q135
Q136
Q137
Q138
Q139
Q140
Q141
Q142
Q143
Q144
Q145
Q146
QC0816
QC0875
QC0875
QC0874
QC0816
QC0773
QC0955
QC0955
QC0955
QC0782
QC0780
QC0762
QC0965
QC0779
EL0059
EY0017
XT0210
XE0090
XT0180
XU0237
XE0094
XE0100
XU0210
XT0180
XE0090
XU0210
XU0210
XU0237
XT0180
XT0180
XT0213
XT0180
XE0053
XT0210
XT0210
XT0180
XT0213
XE0090
XE0053
XE0090
XT0241
XU0237
XT0214
XU0220
XT0212
XE0090
XT0212
XU0237
XT0241
XU0210
XT0212
XU0211
XT0214
XU0213
XU0210
XU0211
XU0211
XU0212
XU0211
XU0210
XU0210
XU0220
MLG1005SR22J-T/A
C2012H68NH
C2012H68NH
C2012H56NH
MLG1005SR22J-T/A
C1608CB-R47J
C1608H-15NG
C1608H-15NG
C1608H-15NG
C1608H-18NJ
C1608H-12NJ
C1608CB-56NJ
LB2012T220K
C1608H-10NJ
L5-0353TRM
OB-27P44 (ROHS)ﾀｲｵｳ
2SC6026MFV-GR(TPL3)
SSM3J15FV(TPL3,Z)
2SC5066FT-Y(T5L,F)
RN47A4JE(TE85L,F)
RD01MUS2-T113
RD07MUS2B-T112
RN1107MFV(TPL3)
2SC5066FT-Y(T5L,F)
SSM3J15FV(TPL3,Z)
RN1107MFV(TPL3)
RN1107MFV(TPL3)
RN47A4JE(TE85L,F)
2SC5066FT-Y(T5L,F)
2SC5066FT-Y(T5L,F)
2SC5659 T2L P
2SC5066FT-Y(T5L,F)
3SK293(TE85L,F)
2SC6026MFV-GR(TPL3)
2SC6026MFV-GR(TPL3)
2SC5066FT-Y(T5L,F)
2SC5659 T2L P
SSM3J15FV(TPL3,Z)
3SK293(TE85L,F)
SSM3J15FV(TPL3,Z)
TPCP8602(TE85L,F)
RN47A4JE(TE85L,F)
HN2C01FE-GR(T5L,F)
RN2111MFV(TPL3)
2SA1955FV-A (TPL3)
SSM3J15FV(TPL3,Z)
2SA1955FV-A (TPL3)
RN47A4JE(TE85L,F)
TPCP8602(TE85L,F)
RN1107MFV(TPL3)
2SA1955FV-A (TPL3)
RN2107MFV(TPL3)
HN2C01FE-GR(T5L,F)
RN1111MFV(TPL3)
RN1107MFV(TPL3)
RN2107MFV(TPL3)
RN2107MFV(TPL3)
RN2115MFV (TPL3)
RN2107MFV(TPL3)
RN1107MFV(TPL3)
RN1107MFV(TPL3)
RN2111MFV(TPL3)
8
Q147
Q148
Q149
Q150
Q151
Q152
Q153
Q154
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
R122
R123
R124
R125
R126
R127
R128
R130
R131
R132
R133
R134
R135
R136
R137
R138
R140
R141
R142
R143
R144
R145
R146
R147
R148
R149
R150
R151
R152
R153
R154
R155
R156
XU0210
XT0241
XT0210
XU0213
XU0210
XU0213
XU0210
XU0210
RK3542
RK3534
RK3526
RK3522
RK3550
NC
RK3530
RK3554
RK3030
RK3552
RK3574
RK3562
RK3526
RK3550
RK3018
RK3530
RK3530
RK3550
RK3550
RK3560
RK3556
RK3526
RK3537
RK3562
RK3562
RK3532
RK3562
RK3538
RK3550
RK3566
RK3558
RK3526
RK3534
RK3546
RK3526
RK3554
NC
RK3550
RK3558
RK3552
RK3550
RK3563
RK3544
RK3550
RK3550
RK3544
RK3556
RK3532
RK3550
RK3534
RK3530
RK3562
RK3562
RK3526
RN1107MFV(TPL3)
TPCP8602(TE85L,F)
2SC6026MFV-GR(TPL3)
RN1111MFV(TPL3)
RN1107MFV(TPL3)
RN1111MFV(TPL3)
RN1107MFV(TPL3)
RN1107MFV(TPL3)
RK73B1ETTP222J
RK73B1ETTP471J
RK73B1ETTP101J
RK73B1ETTP470J
RK73B1ETTP103J
RK73B1ETTP221J
RK73B1ETTP223J
RK73B1JTTD221J
RK73B1ETTP153J
RK73B1ETTP105J
RK73B1ETTP104J
RK73B1ETTP101J
RK73B1ETTP103J
RK73B1JTTD220J
RK73B1ETTP221J
RK73B1ETTP221J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP683J
RK73B1ETTP333J
RK73B1ETTP101J
RK73B1ETTP821J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP331J
RK73B1ETTP104J
RK73B1ETTP102J
RK73B1ETTP103J
RK73B1ETTP224J
RK73B1ETTP473J
RK73B1ETTP101J
RK73B1ETTP471J
RK73B1ETTP472J
RK73B1ETTP101J
RK73B1ETTP223J
RK73B1ETTP103J
RK73B1ETTP473J
RK73B1ETTP153J
RK73B1ETTP103J
RK73B1ETTP124J
RK73B1ETTP332J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP332J
RK73B1ETTP333J
RK73B1ETTP331J
RK73B1ETTP103J
RK73B1ETTP471J
RK73B1ETTP221J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP101J
9
R157
R158
R159
R160
R161
R162
R163
R164
R165
R166
R167
R168
R169
R170
R171
R172
R173
R174
R175
R176
R177
R178
R179
R180
R181
R182
R183
R184
R185
R186
R187
R188
R189
R190
R191
R192
R193
R194
R195
R196
R197
R198
R199
R200
R201
R202
R203
R204
R205
R206
R207
R208
R209
R210
R211
R212
R213
R214
R215
R216
R217
R218
RK3542
RK3550
RK3552
RK3534
RK3546
RK3550
RK3562
RK3562
RK3566
RK3542
RK3538
RK3562
RK3530
RK3566
RK3530
RK3526
RK3562
RK3522
RK3562
RK3562
RK3538
RK3526
RK3556
RK3562
RK3546
RK3570
RK3526
RK3526
RK3570
RK3546
RK3501
RK3543
RK3562
RK3537
RK3566
RK3550
RK3546
RK3546
RK3534
RK3538
RK3562
RK3538
RK3546
RK3574
RK3550
RK3570
RK3550
RK3514
RK3550
RK3526
RK3538
RK3532
RK3574
RK3562
RK3564
RK3522
RK3562
RK3562
RK3562
RK3538
RK3558
RK3562
RK73B1ETTP222J
RK73B1ETTP103J
RK73B1ETTP153J
RK73B1ETTP471J
RK73B1ETTP472J
RK73B1ETTP103J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP224J
RK73B1ETTP222J
RK73B1ETTP102J
RK73B1ETTP104J
RK73B1ETTP221J
RK73B1ETTP224J
RK73B1ETTP221J
RK73B1ETTP101J
RK73B1ETTP104J
RK73B1ETTP470J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP102J
RK73B1ETTP101J
RK73B1ETTP333J
RK73B1ETTP104J
RK73B1ETTP472J
RK73B1ETTP474J
RK73B1ETTP101J
RK73B1ETTP101J
RK73B1ETTP474J
RK73B1ETTP472J
RK73Z1ETTP
RK73B1ETTP272J
RK73B1ETTP104J
RK73B1ETTP821J
RK73B1ETTP224J
RK73B1ETTP103J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP471J
RK73B1ETTP102J
RK73B1ETTP104J
RK73B1ETTP102J
RK73B1ETTP472J
RK73B1ETTP105J
RK73B1ETTP103J
RK73B1ETTP474J
RK73B1ETTP103J
RK73B1ETTP100J
RK73B1ETTP103J
RK73B1ETTP101J
RK73B1ETTP102J
RK73B1ETTP331J
RK73B1ETTP105J
RK73B1ETTP104J
RK73B1ETTP154J
RK73B1ETTP470J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP102J
RK73B1ETTP473J
RK73B1ETTP104J
10
R219
R220
R221
R222
R223
R224
R225
R226
R227
R228
R229
R230
R231
R232
R233
R234
R235
R236
R237
R238
R239
R240
R241
R242
R243
R244
R245
R246
R247
R248
R249
R250
R251
R252
R253
R254
R255
R256
R257
R258
R259
R260
R261
R264
R265
R266
R267
R268
R269
R270
R271
R272
R273
R274
R275
R276
R277
R278
R279
R280
R281
R282
RK3562
RK3574
RK3554
RK3553
RK3526
RK3526
RK3564
RK3574
RK3554
RK3550
RK3562
RK3550
RK3558
RK3542
RK3536
RK3532
RK3546
RK3562
NC
NC
RK3542
RK3552
RK3546
RK3546
RK3546
RK3546
RK3546
RK3546
RK3550
RK3550
RK3562
RK3562
RK3562
RK3562
RK3558
NC
RK3552
RK3538
RK3562
RK3526
RK3536
RK3562
RK3550
RK3566
RK3563
RK3548
RK3552
RK3550
RK3501
RK3538
RK3550
RK3548
RK3542
RK3538
RK3560
NC
RK1018
RK3552
RK3562
RK3554
RK3559
RK3558
RK73B1ETTP104J
RK73B1ETTP105J
RK73B1ETTP223J
RK73B1ETTP183J
RK73B1ETTP101J
RK73B1ETTP101J
RK73B1ETTP154J
RK73B1ETTP105J
RK73B1ETTP223J
RK73B1ETTP103J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP473J
RK73B1ETTP222J
RK73B1ETTP681J
RK73B1ETTP331J
RK73B1ETTP472J
RK73B1ETTP104J
RK73B1ETTP222J
RK73B1ETTP153J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP473J
RK73B1ETTP153J
RK73B1ETTP102J
RK73B1ETTP104J
RK73B1ETTP101J
RK73B1ETTP681J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP224J
RK73B1ETTP124J
RK73B1ETTP682J
RK73B1ETTP153J
RK73B1ETTP103J
RK73Z1ETTP
RK73B1ETTP102J
RK73B1ETTP103J
RK73B1ETTP682J
RK73B1ETTP222J
RK73B1ETTP102J
RK73B1ETTP683J
ERJ8GEYJ101V
RK73B1ETTP153J
RK73B1ETTP104J
RK73B1ETTP223J
RK73B1ETTP563J
RK73B1ETTP473J
11
R283
R284
R285
R286
R287
R288
R289
R290
R291
R292
R293
R294
R295
R296
R297
R298
R299
R300
R301
R302
R303
R304
R306
R307
R308
R309
R310
R311
R312
R313
R314
R315
R316
R317
R318
R319
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
R330
R331
R332
R333
R334
R335
R336
R337
R338
R339
R340
R341
R342
R343
R344
R345
RK3566
RK3562
RK3562
RK3550
RK3550
RK3550
RK3558
RK3558
RK3558
RK3550
RK3562
RK3562
RK3550
RK3554
RK3554
RK3550
RK3558
RK3574
RK3550
RK3556
RK3566
RK3570
RK3550
RK3546
RK3566
RK3568
RK3574
RK3550
RK3550
RK3556
RK3556
RK3536
RK3562
RK3550
RK3017
RK3566
RK3558
RK3562
RK3546
RK3550
RK3558
RK3558
RK3552
RK3562
RK3016
RK3537
RK3562
RK3550
RK3546
RK3562
RK3550
RK3570
RK3552
RK3567
RK3537
RK3550
RK3574
NC
RK3566
NC
RK3538
RK3538
RK73B1ETTP224J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP473J
RK73B1ETTP473J
RK73B1ETTP473J
RK73B1ETTP103J
RK73B1ETTP104J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP223J
RK73B1ETTP223J
RK73B1ETTP103J
RK73B1ETTP473J
RK73B1ETTP105J
RK73B1ETTP103J
RK73B1ETTP333J
RK73B1ETTP224J
RK73B1ETTP474J
RK73B1ETTP103J
RK73B1ETTP472J
RK73B1ETTP224J
RK73B1ETTP334J
RK73B1ETTP105J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP333J
RK73B1ETTP333J
RK73B1ETTP681J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1JTTD180J
RK73B1ETTP224J
RK73B1ETTP473J
RK73B1ETTP104J
RK73B1ETTP472J
RK73B1ETTP103J
RK73B1ETTP473J
RK73B1ETTP473J
RK73B1ETTP153J
RK73B1ETTP104J
RK73B1JTTD150J
RK73B1ETTP821J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP472J
RK73B1ETTP104J
RK73B1ETTP103J
RK73B1ETTP474J
RK73B1ETTP153J
RK73B1ETTP274J
RK73B1ETTP821J
RK73B1ETTP103J
RK73B1ETTP105J
RK73B1ETTP224J
RK73B1ETTP102J
RK73B1ETTP102J
12
R347
R348
R349
R350
R351
R353
R354
R355
R356
R357
R358
R359
R361
R362
R363
R364
R365
R366
R368
R369
R370
R371
R373
R374
R375
R377
R378
R379
R380
R381
SW101
SW102
SW103
TH101
X101
X102
X103
XF0085
RK3554
RK3550
RK3550
RK3550
RK3546
NC
RK3546
RK3546
RK3546
RK3546
NC
RK3555
RK3532
RK3530
RK3501
RK3550
RK3550
NC
RK3544
RK3562
NC
RK3501
RK3574
NC
NC
RK3526
RK3554
RK3554
RK3562
RK0107
UU0041
UU0041
UU0041
XS0052
XQ0194
XK0014
XQ0233
XF0085
FM0265A
DG0046
FG0418
ST0089
TL0033
TS0193
MACLH2GG
UP0660
RK73B1ETTP223J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP472J
RK73B1ETTP273J
RK73B1ETTP331J
RK73B1ETTP221J
RK73Z1ETTP
RK73B1ETTP103J
RK73B1ETTP103J
RK73B1ETTP332J
RK73B1ETTP104J
RK73Z1ETTP
RK73B1ETTP105J
RK73B1ETTP101J
RK73B1ETTP223J
RK73B1ETTP223J
RK73B1ETTP104J
ERJ6GEY0R00V
EVQP4203M
EVQP4203M
EVQP4203M
NTCG104LH104JT/A
NT3225SA 12.800MHZ
CDBKB450KCAY70-R0
DSX530GA 8.192MHZ
DSF753SBF 38.85MHZ
HEAT SINK
LCD LIGHT DJ170
LCD RUB CONE
LCD HOLDER
REFLECTIVE SHEET
VCO CASE DJS57
#30AH1-025-H1
INTEGRATED DJS57
13
Mechanical Unit
Ref.No.
Parts No.
AA0083
AF0003Z
AF0018Z
AF0030
AN0012Z
AN0033
AN0034
AP0039
AX0004Z
DP0210
ES0034
FG0392
FG0416
FG0417
FG0419
FG0420A
FG0421
FG0424
FG0426
FG0427
FG0422
FG0472
FG0503
FK0002
FM0263
FM0264Z
FP0254
FP0255
FP0264
FP0265
FP0266
KZ0240
MACL07AA
MRCL07AA
NK0081
SD0111A
SP0013
SS0103A
UE0502A
UP0535
UR0027
YX0039
Parts Name
M6 WATERPROOF
XQN2+C3FN
XQN2+C4FJK
XQN2+A6FN(58364-0001
ﾀﾞｲﾔﾙﾅｯﾄ ｸﾛﾆｯｹﾙ
BASE NUT
M6 NUT BR/B.N
ﾅﾍﾞP2+20ﾃﾂ 3BBC
PT 3P 2X8 3BBC
LCD PANEL
40-8BB-17
WATERPROOF CAP
BASE RUBBER
DC CAP
WATERPROOF RUBBER
POWER KEY V17
PTT RUBBER
O RING DJ170
MIC RUBBER DJ170
ON AIR RUBBER
KEY RUBBER
CUSHION EDH34
JACK RUBBER DJS57
MIC SPACER DJP82
GROUND DJ170
JACK BASE
REAR COVER DJ170
LOCK LEVER DJV17
BLIND SEAL DJ170
S-NTF1026J 5.8X3.0PH
INSULATION SHEET
FRONT CASE ASSY
#30A02-070-02
#30R02-070-02
KNOB
BATTERY TERMINAL
LECTRA #7800
CHASSIS
SMA CONNECTOR
BATT PANEL BOARD
RH70N97E20 16.2F
LCD TAPE DJS45
Packing Unit
BB0009Y
BH0017
EA0114A
EG0063
EDC160
HAND STRAP
BELT CLIP
ANTENNA
EBP66
NI-MH CHARGER SET
www.ALINCO.ru
DJV57 PC Board View
MAIN - Side A
ALINCO, INC.
DJV57 PC Board View
MAIN - Side B
ALINCO, INC.
PAGE
ADJUSTMENT DJ-V57
In order to adjust the units, mode of them must be changed into “Adjustment mode”.
(1) Change the mode of the unit into “Memory mode”.
Operation: Press the V/M key. (”M” appears on the display)
(2) Change the mode of the unit into “Adjustment mode”.
Operation: Command input after Key Lock. (Command: 4 key > 9 key > 0 key > 2 key > 1 key > 7 key)
ALINCO, INC.
1
PAGE
ADJUSTMENT DJ-V57
2
Required Test Equipment
The following items are required to adjust radio parameters
1.Regulated power supply
Supply voltage: 5-14 DC
Current: 3A or more
2.Digital multimeter
Voltage range: FS = Approx. 20V
Current: 10A or more
Input resistance: High impedance
3.Oscilloscope
Measurable frequency: Audio frequency
4.Audio dummy load
Impedance: 8Ω
Dissipation: 1W or more
Jack: 3.5mmΦ
5.SSG
Output frequency: 100MHz or more
Impedance: 50Ω , unbalanced
Modulation: FM
6.Power meter
Measurable frequency: Up to 100MHz
Impedance: 50Ω , unbalanced
Measuring range: 0.1W-10W
7.Audio volmeter
Measurable frequency: Up to 100kHz
Sensitivity: 1mV to 10V
8.Audio generator
Output frequency: 67Hz to 10kHz
Output impedance: 600Ω , unbalanced
9.Distortion meter/SINAD meter
Measurable frequency: 1kHz
Input level: Up to 40dB
Distortion: 1％-100％
Note:
(1). SSG initial setting
Modulation Frequency:1kHz
10.Frequency counter
Measurable frequency: Up to 100MHz
Measurable stability: Approx. ±0.1ppm
11.Linear detector
Measurable frequency: Up to 100MHz
Characteristics: Flat
CN: 60dB or more
Modulation Level:3.5kHz
(2). Necessary optional accessory: EDS-10 ( Microphone/Speaker Cable )
(3). Reference sensitivity: 12dB SINAD
(4). Specified audio output level: 500mW at 8Ω
(5). Standard audio output level: 50mW at 8Ω
(6). Use an RF cable ( 3D2W:1M ) for test equipment.
(7). Attach a fuse to the RF test equipment.
12. DC Ammeter
Current: 3A or more
(8). All SSG outputs are indicated by EMF
(9). Supply voltage for the transceiver:13.8VDC
ALINCO, INC.
PAGE
ADJUSTMENT DJ-V57
3
·13.8V DC shall be supplied to the DC Jack of the unit.
·Antenna connector shall be connected to a measurement equipment with a 50 ohms shield cable.
·The test frequency can be varied within +/- 0.2MHz when receiving interference or interfering with other productions.
1. Frequency adjusting
Set the memory channel number to [1].
Transmit a signal with the unit and adjust the frequency to the specs by rotating the rotary encoder.
Specs: +/- 50Hz
Condition; ·frequency: 435.000MHz
2. UHF High Power adjusting
Set the memory channel number to [2].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder besides check that the electric current
being supplied to DC Jack is below the specs.
Specs (Power): 5.0W
Condition; ·frequency: 435.000MHz
Note: This adjustment should be quickly performed after transmission is started. If it was not achieved within 5 seconds, the test unit
should be readjusted after cooling down.
3. UHF Middle Power adjusting
Set the memory channel number to [3].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder.
Specs: 2.0W
Condition; ·frequency: 435.000MHz
4. UHF Low Power adjusting
Set the memory channel number to [4].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder.
Specs: 0.5W
Condition; ·frequency: 435.000MHz
5. VHF High Power adjusting
Set the memory channel number to [5].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder besides check that the electric current
being supplied to DC Jack is below the specs.
Specs (Power): 5.0W
Condition; ·frequency: 145.000MHz
Note: This adjustment should be quickly performed after transmission is started. If it was not achieved within 5 seconds, the test unit
should be readjusted after cooling down.
6. VHF Middle Power adjusting
Set the memory channel number to [6].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder.
Specs: 2.0W
Condition; ·frequency: 145.000MHz
7. VHF Low Power adjusting
Set the memory channel number to [7].
Transmit a signal with the unit and adjust the Tx power to the specs by rotating the rotary encoder.
Specs: 0.5W
Condition; ·frequency: 145.000MHz
8. UHF Wide Mic Deviation adjusting
Set the memory channel number to [8].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 4.5 +/- 0.1KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 20KHz
9. UHF Narrow Mic Deviation adjusting
Set the memory channel number to [9].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 2.2 +/- 0.1KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 20KHz
ALINCO, INC.
PAGE
ADJUSTMENT DJ-V57
4
·13.8V DC shall be supplied to the DC Jack of the unit.
·Antenna connector shall be connected to a measurement equipment with a 50 ohms shield cable.
·The test frequency can be varied within +/- 0.2MHz when receiving interference or interfering with other productions.
10. VHF Wide Mic Deviation adjusting
Set the memory channel number to [11].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 4.5 +/- 0.1KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 20KHz
11. VHF Narrow Mic Deviation adjusting
Set the memory channel number to [12].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 2.2 +/- 0.1KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 20KHz
12. UHF Wide CTCSS tone [88.5Hz] Deviation
Set the memory channel number to [14].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder and then check if the waveform of the
tone signal demodulated is sign waveform.
Specs: 0.80 +/- 0.05KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 3KHz
13. UHF Narrow CTCSS tone [88.5Hz] Deviation
Set the memory channel number to [15].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder and then check if the waveform of the
tone signal demodulated is sign waveform.
Specs: 0.50 +/- 0.05KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 3KHz
14. UHF Wide DCS [255] Deviation checking
Set the memory channel number to [16].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 0.80 +/- 0.05KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 3KHz
15. UHF Narrow DCS [255] Deviation checking
Set the memory channel number to [17].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 0.50 +/- 0.05KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 3KHz
16. VHF Wide CTCSS tone [88.5Hz] Deviation
Set the memory channel number to [18].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder and then check if the waveform of the
tone signal demodulated is sign waveform.
Specs: 0.80 +/- 0.05KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 3KHz
17. VHF Narrow CTCSS tone [88.5Hz] Deviation
Set the memory channel number to [19].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder and then check if the waveform of the
tone signal demodulated is sign waveform.
Specs: 0.50 +/- 0.05KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 3KHz
ALINCO, INC.
PAGE
ADJUSTMENT DJ-V57
5
·13.8V DC shall be supplied to the DC Jack of the unit.
·Antenna connector shall be connected to a measurement equipment with a 50 ohms shield cable.
·The test frequency can be varied within +/- 0.2MHz when receiving interference or interfering with other productions.
18. VHF Wide DCS [255] Deviation checking
Set the memory channel number to [20].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 0.80 +/- 0.05KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 3KHz
19. VHF Narrow DCS [255] Deviation checking
Set the memory channel number to [21].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 0.50 +/- 0.05KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 3KHz
20. VHF Wide DTMF tone Deviation
Set the memory channel number to [22].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 3.0 +/- 0.1KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 20KHz
21. VHF Narrow DTMF tone Deviation
Set the memory channel number to [23].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 1.5 +/- 0.1KHz
Condition; ·frequency: 145.000MHz
·AF filter setting: off – 20KHz
22. UHF Wide DTMF tone Deviation
Set the memory channel number to [24].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 3.0 +/- 0.1KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 20KHz
23. UHF Narrow DTMF tone Deviation
Set the memory channel number to [25].
Transmit a signal with the unit and adjust the deviation to the specs by rotating the rotary encoder.
Specs: 1.5 +/- 0.1KHz
Condition; ·frequency: 435.000MHz
·AF filter setting: off – 20KHz
24. UHF Sensitivity [SINAD] center range adjusting
Set the memory channel number to [28].
Receive a RF signal with the unit and adjust the
audio output power of the SP Jack to approximately
50mW by the volume adjustment function.
Specs: [SINAD] 12dB or better
Condition; ·frequency: 435.000MHz
·RF signal level: -8.0dBµ
·SQL setting: 0
·modulation frequency with RF signal: 1KHz
·modulation level (deviation) with RF signal: 3.5KHz
Press “FUNC” key and then tune the
sensitivity by rotating the rotary encoder so
that it will be the best and pass the specs.
Note: In order to finish this adjustment and proceed
to next step, press “FUNC” key.
25. VHF Sensitivity [SINAD] center range adjusting
Set the memory channel number to [31].
Specs: [SINAD] 12dB or better
Condition; ·frequency: 145.000MHz
·RF signal level: -9.0dBµ
·SQL setting: 0
·modulation frequency with RF signal: 1KHz
·modulation level (deviation) with RF signal: 3.5KHz
ALINCO, INC.
PAGE
ADJUSTMENT DJ-V57
6
·13.8V DC shall be supplied to the DC Jack of the unit.
·Antenna connector shall be connected to a measurement equipment with a 50 ohms shield cable.
·The test frequency can be varied within +/- 0.2MHz when receiving interference or interfering with other productions.
Condition of Squelch, S-meter and Attenuator adjusting.
·modulation frequency with RF signal: 1KHz
·modulation level (deviation) with RF signal: 3.5KHz
·SQL setting: 0
Operation of Squelch and S-meter adjusting.
Receive a RF signal with the unit and press “FUNC” key.
26. UHF Squelch [Min.] adjusting
Set the memory channel number to [33].
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: -11dBµ
27. UHF Squelch [Max.] adjusting
Set the memory channel number to [34].
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: 0dBµ
28. UHF S-meter [1] level adjusting
Set the memory channel number to [35].
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: 0dBµ
29. UHF S-meter [Full] level adjusting
Set the memory channel number to [36].
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: 20dBµ
30. UHF Attenuator-1 adjusting
Set the memory channel number to [37].
Receive a RF signal with the unit.
Press “FUNC” key and then reduce the number of the S-meter between “4” and “5” by rotating
the rotary encoder.
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: 24dBµ
Note: In order to finish this adjustment and proceed to next step, press “FUNC” key.
This must be performed after S-meter adjustments.
OK
OK
Flashing
NG
31. UHF Attenuator-2 adjusting
Set the memory channel number to [38].
Receive a RF signal with the unit.
Press “FUNC” key and then reduce the number of the S-meter between “1” and “2” by rotating
the rotary encoder.
Condition; ·frequency: 435.000 +/- 0.2MHz
·RF signal level: 24dBµ
OK
Note: In order to finish this adjustment and proceed to next step, press “FUNC” key.
This must be performed after S-meter adjustments.
NG
ALINCO, INC.
OK
Flashing
PAGE
ADJUSTMENT DJ-V57
7
·13.8V DC shall be supplied to the DC Jack of the unit.
·Antenna connector shall be connected to a measurement equipment with a 50 ohms shield cable.
·The test frequency can be varied within +/- 0.2MHz when receiving interference or interfering with other productions.
Condition of Squelch, S-meter and Attenuator adjusting.
·modulation frequency with RF signal: 1KHz
·modulation level (deviation) with RF signal: 3.5KHz
·SQL setting: 0
Operation of Squelch and S-meter adjusting.
Receive a RF signal with the unit and press “FUNC” key.
32. VHF Squelch [Min.] adjusting
Set the memory channel number to [39].
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: -12dBµ
33. VHF Squelch [Max.] adjusting
Set the memory channel number to [40].
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: 0dBµ
34. VHF S-meter [1] level adjusting
Set the memory channel number to [41].
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: 0dBµ
35. VHF S-meter [Full] level adjusting
Set the memory channel number to [42].
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: 20dBµ
36. VHF Attenuator-1 adjusting
Set the memory channel number to [43].
Receive a RF signal with the unit.
Press “FUNC” key and then reduce the number of the S-meter between “4” and “5” by rotating
the rotary encoder.
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: 24dBµ
OK
OK
Flashing
NG
Note: In order to finish this adjustment and proceed to next step, press “FUNC” key.
This must be performed after S-meter adjustments.
37. VHF Attenuator-2 adjusting
Set the memory channel number to [44].
Receive a RF signal with the unit.
Press “FUNC” key and then reduce the number of the S-meter between “1” and “2” by rotating
the rotary encoder.
Condition; ·frequency: 145.000 +/- 0.2MHz
·RF signal level: 24dBµ
Note: In order to finish this adjustment and proceed to next step, press “FUNC” key.
This must be performed after S-meter adjustments.
Storage to Flash Memory
Select the memory channel number to [45].
[FLASH] is displayed.
“ Press FUNC key ”
(Adjustment data is stored into Flash Memory of CPU.)
ALINCO, INC.
OK
OK
NG
Flashing
R355
4.7k
R354
4.7k
*
0
SW117
SW118
#
SW119
9
C
SW113
SW114
SW115
SW116
SW120
KI1
D
KI0
IC114
R1EX24064ATAS0
Q153
RN1107MFV
R348
10k
R349
10k
R350
10k
R351
4.7k
BEEP
D153
RB521S-30
R345
1k
C403
0.001
R323
10k
SMLD12M8W SMLD12M8W
Q149
2SC6026MVF
+B
R334
10k
R335
470k
R292
10k
IC112
LM2902PWR
C364
1
R293
100k
R294
100k
VDET
C357
0.01
D151
R339
RB521S-30 10k
1
8
2
7
3
6
4
5
R330
100k
R371
0
IC116
NC
R289
47k
C344
1
20
R279
100k
C5V
R290
47k
C5V
Q141
RN2107MFV
M5C
CN102
NC
SSTB 19
9
DMOD
CLK
18
10
8
MCI
DATA 17
7
T5V
16
6
SCR
15
5
DUD
14
4
13
3
AFI
12
2
DAFO
11
1
R337
270k
R5V
R5C
T5V
NAR
T5C
C358
NC
C5C
C5V
C387
100p
IC110
LM2902PWR
R380
100k
C5V
Q129
2SA1955FV
R251
100k
Q135
2SA1955FV
R260
100k
R269
0
NC
+IN
V+
-IN
OUT
GND
GND
+
Q125
TPCP8602
+
R315 C380
0.01
680
R309
330k
+
C419
0.001
NC
5
Q131
2SA1955FV
Q144
RN1107MFV
R344
1k
R374
NC
7
APC
MUTE
C359
0.047
Q145
RN1107MFV
R378
22k
R5V
C272
100/10V
MICC
R307
4.7k
C381
0.0047
Q148
TPCP8602
R276
NC
D152
CMS01
D154
CMS01
D113
015AZ3.0
8
7
C140
0.001
C136
10p
R114
10k
GPO2
DVSS
VREF
RFINN
RFINP
R126
330
C168
100p
C160
0.01
LD
9
R375
NC
R143
10k
C159
0.001
10
DMOD
REFIN
PVDD
CP
R379
22k
TMOD
C131
1p
REF
R358
NC
R148
3.3k
11
21
C278
0.001
6
+
PDN2
C194
0.1
CLK
DATA
LE
CPVSS
C290 R204
0.1
10
6
5
4
TEST1
TEST3
CPVDD
C201
0.1/20V
R138
NC
R134
470
12
TEST2
C316
0.001
+
3
R133
100
GPO1
PVSS
C303
0.001
4
C315
0.001
3
C302
0.001
2
PDN1
C365
100p
R250
100k
BIAS
20
C352
0.1
BEEP
1
R282
47k
AFP
SWIN
C318
2.2/16V
4 CLK
C193
0.001
CLK
R162
10k
C332
0.001
C267
0.1
19
IC102
AK1542
C339
0.001
P5V
C416
0.1
R158
10k
C317
0.001
DATA
2
1
R157
2.2k
R232
2.2k
R222
18k
R151
10k
CPZ
C331
0.001
R227
22k
C415
0.001
24
R272
6.8k
Q139
RN1107MFV
R201
10k
23
C301
0.001
R208
330
APC
STBP
R231
47k
C300
47/16V
P3V
C294
1/16V
C209
1/16V
C196
0.001
R140
10k
D117
1SV308
22
C340
10/6.3V
C324
0.001
C205
0.001
L127
8.2n
+
C330
47/6.3V
P5C
R240
15k
L129
2.7n
D119
1SV305
R144
120k
TP101
R256
1k
C329
0.001
R154
100k
D124
1SV305
C195
0.5p
R142
15k
C197
6p
C182
470p
C181
0.1
C189
470p
L123
47n
TH101
100k
C429
4.7/6.3V
C180
4.7/6.3V
C179
0.001
1
2
3
4
R359
27k
R261
10k
Q134
RN1107MFV
R255
15k
V+
D123
HSC277
C206
10p
R153
220
R152
470
8
GND
R145
3.3k
R296
22k
R327
100k
C351
0.001
R271
10k
R265
120k
C333
0.001
TMOD
R295
10k
C398 R333
1
100k
C275
NC
C274
0.01
C213
470p
C214
0.1/20V
+
R266
6.8k
C417
10/6.3V
R373
1M
L117
220n
C161
0.001
13
14
15
16
17
18
C163
0.1/20V
C162
0.001
C165
0.001
C164
220p
C158
0.001
C157
0.01
C156
10/6.3V
C123
1p
C122
22p
C121
27p
C129
NC
C128
NC
C127
33p
C126
39p
C125
39p
C124
1p
R115
22
L108
56n
C139
220p
C144
0.01
L115
39n
C133
0.001
R113
100
L114
100n
C135
12p
R116
220
R109
220
L148
10n
C138
0.001
D112
1SV323
R124
100k
L111
1u
L113
0.4-2.0-6TL
C425
0.001
D111
HSC277
C151
22p
R123
820
R122
100
R127
100k
C120
15p
C119
NC
L110
0.4-2.0-6TL
FB101
MPZ1608S101
R125
100k
C153
0.001
C152
220p
C154
0.001
C414
100p
C379
0.001
C391
0.001
C291
0.1
C418
0.1
L135
220n
C233
68p
C211
0.001
7
6
5
FB103
MPZ1608S101
C150
220p
C149
0.001
C148
0.01
C147
1/25V
R119
10k
C143
1p
C142
1p
R118
10k
C146
0.001
L112
62n
C112
22p
R105
10k
C104
0.001
C105
0.1
R107
220
R106
NC
D104
1SV308
D106
1SV323
R111
1M
C132
0.5p
C221
NC
C106
0.001
L106
100n
R110
15k
C134
18p
C220
6p
Q114
2SC5066
C372
0.001
R314
33k
R194
4.7k
8
R369
100k
R221
22k
R209
1M
R182
470k
R181
4.7k
L133
220n
C240
0.01
L132
220n
C224
68p
C231
68p
R167
1k
R171
220
R172
100
C241
0.001
T5V
7
C400
0.047
9
R275 C345
68k 2.2/16V
6
C363
0.1
R311
10k
R264
220k
10
C335
1
C384
0.001
H: Narrow
11
R249
100k
+
5
GND
MOD
V+
3 LDDA
R226
1M
4
1
C402
NC
AFOUT
R220
1M
R200
1M
R199
4.7k
Q122
SSM3J15FV
12
2
Q118
2SC6026MVF
3
V IN2
6 AFIN
R340
1M
REF
R316
100k
AFC
C386
680p
LD
13
V DD
C306
0.1
2
CLK
5 DATA
C392 R319
1
220k
DI
R229
100k
V IN3
R254
NC
IC106
R2A20178NP
C266
1/25V
7
8
R189
100k
C322
0.1
V OUT3
9
IC115
NC
C323
0.001
GND
C256
0.0022
14
NAR
R253
47k
V OUT2
V IN4
C255
0.0022
R268
15k
R267
10k
R258
100
V OUT4
R366
NC
24
V IN7
V IN1
18
10
1
V OUT1
RESET
11
2
23
V
V IN5
12
C258
0.1
3
7
22
17
V IN8
16
DAref2
V OUT5
V OUT6
V DAref1
V OUT8
15
V OUT7
V IN6
14
21
13
20
19
R198
1k
C265
0.01
9
10
11
12
13
14
15
16
C253
0.1
C252
0.1
4
6
C382
0.001
R370
NC
R5V
TUNE
C305
220p
ATT
R235
4.7k
C287
0.001
AF OUT
QUAD
IF OUT
RSSI
N-DET
N-REC
GND
MIX IN
R196
1k
R187
0
R297
22k
IC111
LM2904PWR
1
C375
0.01
R313
33k
C327
22/6.3V
R239
2.2k
R368
3.3k
FIL IN
FIL OUT
DEC
IF IN
Vcc
MIX OUT
OSC OUT
OSC IN
R211 C286
150k 0.001
8
7
6
5
4
3
2
1
R207
1k
R193
4.7k
R5V
C362
0.0068
R291
47k
1
C385
0.1
2
Q132
RN47A4JE
C427
NC
R242
4.7k
C313
0.1
C312
0.1
C311
0.1
R228
10k
C309
0.001
C308
0.01
C307
22/6.3V
C285
0.01
C273
6p
L140
470n
C264
33p
C230
10p
R287
10k
4
R312
10k
C388
0.001
DTMF
R321
100k
R252
100k
R246
4.7k
D138
1SS364
5
Q107
RN1107MFV
C212
0.001
R160
470
C108
22/6.3V
C107
0.001
C428
0.001
R332
4.7k
R325
47k
R317
10k
C348
0.1
R245
4.7k
R244
4.7k
R238
NC
8
L130
100n
Q111
RN1107MFV
C361
220p
IC113
S80845CLNB
V+
6
Q130
SSM3J15FV
Q119
2SC6026MVF
3
+B
4
Vss
C314
220p
R186
4.7k
D122
HSC277
+
R163
100k
C409
0.001
KI3
R299
47k
R205
10k
R185
470k
R141
47k
C217
6p
D147
1SS400
R324
47k
C347
0.001
R5V
IC105
NJM2591V
C262
0.01
8
5
R192
10k
D107
HSC277
C407
0.001
3
R188
2.7k
C200
0.001
R156
100
D101
1SS400
R101
2.2k
C102
0.001
C101
1
C426
NC
R102
470
Q101
2SC6026MFV
C406
220p
NC
C261
0.01
C190
6p
C408
47/16V
Vdd
CF102
C325
C326
0.1 CFUKG450G 0.1
R136
100
R128
1k
R280
22k
Vss
R206
100
C284
0.01
X102
C249
33p CDBKB450KCAY70
L116
2.2u
R286
10k
2
OUT
Vin
R225
150k
R170
220k
V/U
R281
56k
MUTE
R5V
GND
10
C346
1/25V
D137
1SS364
R306
10k
Vout
Q115
2SC5659
C137
0.01
Q104
RN47A4JE
C354
0.001
1
R308
220k 1
Q113
2SC5066
7
TONE
+
1
14
C223
7p
C114
18p
C353
10/6.3V
NAR
IC108
XC6202P502M
R303
220k
16 TBST
R302
33k
15 CLSFT
R103
100
C350
0.001
DTMF
2
C171
0.001
C170
0.1
R137
22k
L122
0.5-1.4-2TL
C166
470p
C192
39p
D118
D156
JDP2S04E JDP2S04E
D110
HSC277
D109
HSC277
C145
18p
C118
27p
C117
33p
C116
NC
Q102
SSM3J15FV
C349
1/25V
P13_3
3
R5V
C204
1p
R326
15k
DA1
17 AFC
CF101
C319
C320
0.1 CFUKG450E 0.1
R149
33k
R331
10k
DA0
7
C203
100p
C390
1/25V
P13_2
C283
0.001
C222
0.01
Q108
2SC5066
C397
0.001
P2_2
4
R322
4.7k
Q146
RN2111MFV
D120
1SS364
C389
0.001
WKUP0
8
C113
10p
C396
10/6.3V
VREF
18 RE1
Q103
2SC5066
6
MODE
P2_4
R237
NC
C141
1p
5
P2_5
9
C216
0.001
L125
470n
IC103
LM2904PWR
C366
0.0022
XCIN
Q140
RN2107MFV
3
C401
1
R341
NC
XCOUT
R248
10k
R243
4.7k
R5V
D103
HSC277
R285
100k
P2_6/KI6
11
R135
4.7k
R298
10k
KI7
12
+B
TONE
RESET
R247
10k
R241
4.7k
ATT
14
SEG24
13
1
Q126
RN47A4JE
D144
1SS362
XIN
D142
RB521S-30
D128
1SV308
2
VSS
1
2
13
XOUT
2V/U
R191
220k
R104
47
3
IC109
R5F2L3ACANFP
24 C/S
Q121
2SC5659
C103
100p
12
SEG25
R202
470k
G
R301
10k
VCC
V+
P11_7
SEG28
GND
SEG29
19 RE2
C260 R190
0.01
820
G
4
P11_6/TRBO
21 RXD
R274
1k
5
APC(RLMP)
XF101
38.85MHz
1
11
SEG30
3
R278
15k
Q136
RN2107MFV
2
3
C257
0.01
4
C356
0.001
INT3
Q120
2SC5066
G
5
P11_5
R178
100
R121
10k
5
10
INT4
SEG31
20 TXD
Q116
2SC5066
C130
0.001
Vcc
C394
0.0033
SEG32
22 CLO
G
IC107
TC75S56FU
C229
1p
L109
10n
C373
0.0033
SEG33
6
6
TXD2
23 FSK
Q105
RD01MUS2
9
SEG34
C424
6p
C355
10/6.3V
RXD2
R288
10k
SEG35
R165
220k
C374
0.1
P11_0
25 M5C
C341
0.001
+B
V+
R257
100k
4
Q124
SSM3J15FV
R131
220k
7
P10_7
SEG36
C263
0.001
R277
100
C334
0.1
R365
10k
R169
220
C228
1p
C377
0.001
P10_6
SEG37
C215
0.1
C188
0.5p
C187
12p
C186
10p
C185
1p
C191
5p
C184
6p
D116
JDP2S04E
L124
0.4-1.4-5TL
C199
0.5p
R147
10k
R146
10k
C198
0.5p
C202
100p
T5V
C369
47/6.3V
SEG38
R161
4.7k
C219
0.001
L121
0.4-1.2-5TR
L126
C183
0.4-1.4-5TL 39p
Q112
RN47A4JE
C376
1/25V
P10_5
C248
0.01
R177
1k
R155
100k
C208
470p
D126
1SV308
D125
1SV308
C210
5p
R159
15k
R273
2.2k
LCD101
C328
2.2/16V
R195
470
R184
100
C367
0.1
SEG39
C169
0.1
8
P2_3
R183
100
C250
0.001
L139
220n
L134
68n
C232
NC
D130
1SV323
R168
100k
R166
2.2k
D129
1SV323
C243
47p
C368
0.001
D141
SMLD12M8W
X103
8.192M
5
L147
22u
D139
SML521MUW
2
C383
1/25V
4
C371
18p
R219
100k
R216
1k
D132
1SS364
1
3
C378
15p
C321
0.001
R224
100
L146
56n
C293
47p
R310
1M
26 SSTB
27 LDDA
28 STBP
Q128
RN2111MFV
R300
1M
P10_4
P10_3
P10_2
P10_1
R223
100
C393
0.1
P13_4
P13_5
C304
470p
R176
100k
C246
100p
R175
100k
C245
100p
C234
NC
L136
68n
V/U
IC101
uPC2710TB
D155
1SS362
P1_7
MICC 100
P2_0
P13_6/TRGIOB
P13_7
29 DATA
30 CLK
31 COM0
32 COM1
L142
15n
C277
1p
D135
1SV331
L141
15n
C276
2p
D134
1SV331
R203
10k
C271
1.5p
PTTK 99
P2_1
BEEP 98
97
P10_0
COM0
COM1
C292
NC
CHG
VL4
P12_2
P12_3
R215
100k
C298
8p
R214
100k
C297
8p
R213
100k
R174
47
C244
0.001
C242
NC
R130
10k
R320
47k
95
33 COM2
COM0
COM1
COM2
COM3
S0
D133
1SV331
C279
NC
R179
33k
C239
0.001
L138
56n
C238
NC
R180
100k
C227
2p
C405
0.001
94
VL4 96
SDA
COM2
COM3
34 COM3
35 SEG31
COM0 36
COM1 35
COM2 34
S1
C296
9p
R212
47
L143
15n
C270
0.5p
SCL
VL3
VL2
SEG55
SEG54
36 SEG30
37 SEG29
32
31
COM3 33
SEG0
SEG1
S2
S3
S4
S5
C295
470p
C289
470p
C251
0.001
D127
1SV329
VL3 93
VL1
P0_0
SEG53
38 SEG28
39 SEG27
40 SEG26
41 SEG25
42 SEG24
43 SEG23
44 SEG22
45 SEG21
46 SEG20
47 SEG19
48 SEG18
49 SEG17
30
29
28
27
S6
S7
S8
S9
S10
S11
R217
47k
L145
12n
C288
NC
R218
100k
R210
100k
VL2 92
VL1 91
P0_1
SEG52
SEG51
SEG50
SEG49
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
50 SEG16
SEG2
SEG3
SEG4
SEG5
26
25
24
23
S12
S13
S14
S15
S16
S17
C310
470p
D131
1SV323
R361
330
R342
220k
D150
90
75
89
KO3
KI0
74
KI1
73
P0_2
T5C
AFP
88
72
KI2
P5C
SEG26
P0_3
71
SEG27
87
70
R5C
C269
0.5p
KI3
69
C5C
AN8
V/U
AN9
68
AN10
67
BAT 84
PSW
LAMP
DUD 85
66
VDET 86
SEG0
AN11
65
AN12
64
SEG1
SMT 83
SEG2
AN13
63
AN14
62
SEG3
82
SEG4
81
61
TIN
60
SEG5
SQL
SEG6
FKEY 80
59
AN15
58
SEG7
79
SEG8
SCR
57
P1_4
SEG9
P1_5
FKEY
SEG6
SEG7
SEG8
SEG9
SEG10 22
SEG11 21
SEG12 20
SEG13 19
SEG14 18
SEG15 17
SEG16 16
S18
C268
100p
R150
330
R132
47k
R120
68k
R336
15k
8
R173
100k
C226
1.5p
C178
8p
C423
7p
C399
0.001
7
KI2
Q117
3SK293
C225
0.001
Q109
SSM3J15FV
Q106
RD07MUS2B
CN101
SW112
Q110
RN1107MFV
C177
6p
4
SW111
D121
RB715W
D114
1SV307
C167
7p
3
SW110
C247
100p
R164
100k
C176
470p
L105
0.5-1.4-3TL
2
SW109
L120
0.4-1.4-5TL
C422
6p
1
B
R377
100
R347
22k
SW108
6
R362
220
D108
RB715W
R353
NC
SW107
5
R117
220
W103
NC
SW106
4
+B
P1_6
SEG10 56
78
SEG11 55
77
SEG12 54
KO0
SEG13 53
KO1
SEG14 52
76
RE2
KO2
RH70N97E20
L104
0.4-1.4-5TL
C412
0.1
SW105
Q123
3SK293
R364
10k
PSW
R343
NC
R284
100k
6
SEG15 51
5
FUNC
SCL
PTT
C155
0.001
C411
0.01
A
C282
100p
SDA
SW101
EVQP4203M
D102
1SV307
C410
0.01
3
S19
C281
1.5p
GND
2
SEG17 15
R197
100k
A2
1
C237
0.001
3
D145
D146
R329 SMLD12M8W SMLD12M8W
820
SEG18 14
D136
1SV331
C299
8p
L137
68n
C236
4p
4
RE1
C175
NC
WP
MONI
C174
15p
A1
R363
0
SEG19 13
S20
S21
S22
L144
18n
L119
0.4-1.4-5TL
KO3
LAMP
C336
0.001
SEG20 12
S23
S24
S25
S26
C173
6p
C111
0.001
7
Q152
RN1111MFV
C404
0.01
Q138
RN1111MFV
SEG21 11
SEG22 10
9
8
7
R234
330
R233
680
C110
15p
2
8
R283
220k
C109
3p
VCC
D149
SEG23
SEG24
SEG25
S27
S28
S29
S30
S31
C235
33p
A0
SW103
EVQP4203M
Q143
RN2107MFV
SW102
EVQP4203M
R304
470k
D140
SMLD12M8W
L102
0.4-1.4-5TL
1
Q150
RN1111MFV
C395
0.001
C343
0.01
6
5
4
3
2
1
C280
8p
R357
4.7k
R338
820
SEG26
SEG27
SEG28
SEG29
SEG30
SEG31
C172
8p
KO0
SW104
C370
NC
C342
0.01
R259
680
R356
KO1 4.7k
KO2
KO3
L103
0.4-2.0-6TL
L101
0.4-2.0-6TL
L107
56n
P5V
C218
100p
C207
0.22
FB102
MPZ1608S101
X101
12.8M
R112
100k
C421
NC
R108 C115
1
22k
Q154
RN1107MFV
IC104
NJM2070M
P5V
8
TP103
W101
SP101
TP104
W102
3
6
C5V
Schematic diagram DJ-V57
JK101
HSJ1594-010150
2
1
7
R230
10k
Q127
HN2C01FE
R236
100k
Q133
TPCP8602
Q137
HN2C01FE
R270
1k
C5V
TBST
Q142
RN2115MFV
C360
0.047
MIC101
OB-27P44
D143
S3JB
JK102
LD-0208-1.3
Q147
RN1107MFV
R318
18
R328
15
D148
1SS362
Q151
RN1107MFV
FB104
MPZ1608S101
R381
0
Ni-MH
C5V
GND
FB106
FBMH1608HM151
Li-ion
VHF ANT FILTER
V-V5V
LPF
ANT SW
LPF
D102 1SV307
D109 HSC277
D110 HSC277
V-T5V
LPF
HPF
DRIVER
PRI-DRIVER
TX-SW
BUFFER AMP
Q106
RD07MUS2B
Q105
RD01MUS2
IC101
uPD2710TB
D103
1SV308
Q113 2SC5066
+B
UHF ANT FILTER
VHF VCO
POWER AMP
D120 1SS364
V-V5V
T5V
T5V
+B
Q103
D106
D112
D111
LOOP FILTER
2SC5066
1SV323
1SV323
HSC277
MOD
APC
D108
RB715W
IC103
LM2904PWR
TCXO
IC102
AK1542P
X101
12.8MHz
F-SHIFT
U-V5V
3V
D113
015AZ3.0
UHF VCO
T5V
TMOD
U-V5V
ANT SW
D114 1SV307
D125 1SV308
D126 1SV308
REF
P5V
STB
CLK
DATA
D104 1SV308
D107 HSC277
Q107 RN1107
POWER DET
PLL IC
Q108
D119
D124
D123
APC
POWER DET
2SC5066
1SV305
1SV305
HSC277
P5V
MOD
BUFFER AMP
U-T5V
D121
RB715W
Q114
2SC5066
F-SHIFT
D117 1SV308
D122 HSC277
Q111 RN1107
P5V
VHF FRONT-END
BPF
D131
1SV323
RF AMP
BPF
Q117
3SK293
D127 1SV329
D129 1SV323
D130 1SV323
V-R5V
BUFFER AMP
1st Lo-SW
Q116
2SC5066
D128
1SV308
ATT
R5V
R5V
TRIPLER
DISCRIMINATOR
Q115
2SC5659
X102
TUNE
SQL
UHF FRONT-END
SMT
SPEAKER
R5V
BPF
D136
1SV331
RF AMP
BPF
BAND SW
Q123
3SK293
D133 1SV331
D134 1SV331
D135 1SV331
D132
1SS364
U-R5V
V-R5V
ATT
U-R5V
1st MIXER
Q120
2SC5066
MCF
IF AMP
XF101
38.85MHz
Q121
2SC5659
IF DETECTOR
IC105
NJM2591V
AF AMP
ACTIVE FILTER (HPF)
AF MUTE
AUDIO AMP
Q119
2SC6026MFV
Q118
2SC6026MFV
Q122
SSM3J15FV
IC104
NJM2070M
R5V
R5V
R5V
R5V
N/W SW-I
AFC
AUDIO SW
N/W SW-O
Q125 TPCP8602
D137
1SS364
TUNE
D138
1SS364
APC
Q127 HN2C01FE
REF
D/A CONVERTER
(POTENTIO METER)
MIC/SPEAKER JACK
AFP
CERAMIC FILTER
TX/RX LAMP
Q130
SSM3J15FV
Q132
RN47A4JE
RX LAMP SW
D139
SML521MUW
Q128
RN2111MFV
T5V
LDDA
CLK
DATA
CF101
450KHz
(WIDE)
IC106
R2A20178NP
CLONE
D142
RB521S-30
Q140
RN2107MFV
TXD/RXD
APC(RLMP)
NAR
CERAMIC FILTER
R5V
ATT
TUNE
CF102
450KHz
(NARROW)
R5V
TMOD
TONE/DCS DET
TIN
MOD
ACTIVE FILTER (LPF)
IDC/SPLATTER FILTER
IC111 (1/2)
LM2904PWR
IC110
LM2902PWR
TONE/DTMF
MIC MUTE
MIC
Q144
RN1107MFV
IC112
LM2902PWR
CPU
ROTARY ENCODER
+B
FSK
MUTE
M5V
R5V
FSK DET
FSK
DISPLAY
MIC-SW
VOX DET
IC107
TC75S56FU
Q136
RN2107MFV
D151
RB521S-30
VDET
MICC
PTT-SW
Q145
RN1107MFV
PTTK
PTT
Q142
RN2115MFV
FUNC
XTAL OSC
LCD
CLOCK SHIFT
R5V
X103
8.192MHz
C5V
Q146
RN2111MFV
MONI
LCD BACK LIGHT
D140 SMLD12M8W
D141 SMLD12M8W
Q138
RN1111MFV
2
3
RESET
IC109
R5F2L3ACANFP
KEY INPUT
1
POWER
RIPPLE FILTER
IC113
S80845CLNB
A
V-V5V
U-V5V
4
5
6
B
7
8
9
C
*
0
#
VDD
D
P5V
Q101
2SC6026MFV
C5V
V-R5V
U-R5V
Q124
SSM3J15FV
Q126
RN47A4JE
REGULATOR
Q131
2SA1955FV
D146 SMLD12M8W
D149 SMLD12M8W
D150 SMLD12M8W
V/U
Q149
2SC6026MFV
Q137 HN2C01FE
CHARGER
Q148 TPCP8602
Q151 RN1107MFV
D148 1SS362
D147 1SS400
BATTERY
Ni-MH
R5C
Q109
SSM3J15FV
Q112
RN47A4JE
Q135
2SA1955FV
EEP ROM
IC114
R1EX24064ATAS0
CHG
T5V
V-T5V
U-T5V
RECEIVE
Q133 TPCP8602
D152
CMS01
BATTERY DET
D145 SMLD12M8W
DC JACK
D143
S3JB
P5C
R5V
+B
KEY BACK LIGHT
Q150
RN1111MFV
Q152
RN1111MFV
+B
Q129
2SA1955FV
V/U
5V REGULATOR
IC108
XC6202P502M
Q102
SSM3J15FV
Q104
RN47A4JE
V/U
D154
CMS01
BATTERY
Li-ion
T5C
TRANSMIT
RECEIVE/TRANSMIT
VDD
M5V
Q141
RN2107MFV
CPU CONTROL
M5C
Block diagram DJ-V57
15
16