Download Service Manual
Transcript
S/M No. : FR33000012 Service Manual Refrigerator Model: FR-330 ✔ Caution : In this Manual, some parts can be changed for improving, their performance without notice in the parts list. So, if you need the latest parts information,please refer to PPL(Parts Price List) in Service Information Center (http://svc.dwe.co.kr). DAEWOO ELECTRONICS CO., LTD. CONTENTS 1. SPECIFICATION 1 2. NAME OF PARTS 2 3. REFRIGERANT CYCLE DIAGRAM 3 4. WRING DIAGRAM 4 5. MACHINE ROOM VIEW AND PART LIST 5 6. METHODS OF EXCHANGING MAIN PARTS 6 7. EXPLODE VIEW AND PARTS LIST 10 8. PARTS LIST 11 1.Specification Refrigerant 115g R134a COOLING System Fan Cooling Convection Type Refrigeration System Air Forced Convection Defrost System Forced Fin-Evaporator Type Defrost Operation Automatic Start & Stop Cold Control Adjustable Dial Capacity External Dimension Freezer 61L Refrigerator 207L Total 268L Height 1636mm Width 600mm Depth 687mm Net Weight 57Kg -1- 2. NAME OF PARTS -2- 3. REFRIGERANT CYCLE DIAGRAM -3- 4. WRING DIAGRAM -4- 5. MACHINE ROOM VIEW AND PART LIST NO PART NAME NO PART NAME NO PART NAME 1 BASE CAB AS 7 PIPE HOT 13 BASE COMP AS 2 COMPRESSOR 8 DRYER AS 14 BRACKET EARTH 3 P-RELAY AS 9 PIPE SUC AS 15 POWER CORD AS 4 PIPE VAPORI AS 10 PIPE SUC CONN 16 ABSORBER PIPE A 5 ABSORBER PIPE B 11 BOX POWER AS 6 PIPE S *PLT 12 HARNESS EARTH -5- 6. METHODS OF EXCHANGING MAIN PARTS (1) Freezing room louver 1) Unscrew, remove the F-louver by pulling forward with inserting screwdriver into the hole of F louver. 2) Assemble it by pressing triangle shape ( ) by hand. (2) R control box 1) After pressing both bottom surfaces of shade and pull forward. 2) To exchange the interior lamp, unscrew the lamp counterclockwise. 3) Remove two screws -6- Methode of exchanging main parts 4) Pull slightly forward with instant force. 5) Remove the housing 6) After romoving the control switch knob and two screws for fixing control switch, change the control switch to new one. -7- Methode of exchanging main parts (3) Bimetal 1) Cut off the wire bind. 2) Take out the bimetal. BIMETAL (4) Glass tube heater 1) Remove 2 screws that fasten the evaporator. 2) Slightly pull the evaporator to the arrow's direction. 3) Move the entire eveporator upward the pipe center to the arrow's direction. (Do not crumble the part A of the accumulator during the process.) -8- Evaporator fastening screw Methode of exchanging main parts 4) Cut the both ends of glass tube heater tube heater lead wires and insulate and seal lead tip remaining in refrigerator with tape etc. Raise d Heater Cover Glass tube heater Lead 5) Pull out the glass tube heater from the heater Heater fi t supporter with heater covers remaining. (upper and lower) (Do not apply much power on the heater supporter.) Heater Cover Heater Cover 6) Install the heater covers (upper and lower) on a new glass tube heater. (Make the cover with holes the lower one) Heater Cover AL Frontsid 7) Place the glass tube heater lead wire shown Lead as below and fasten the shaded area with type. 8) Fin insert the lead wire connection terminals. (Same colored lead wires) 9) Set the evaporator on normal position and Glass tube h t secure the fastening screws. -9- 7. EXPLODE VIEW AND PARTS LIST 1. Expoloded views JORDAN MIDDLE (DAEWOO,FR-330) -10- ✔ Caution: In this Service Manual, some parts can be changed for improving, their performance without notice in the parts list. So, if you need the latest parts information, please refer to PPL(Parts Price List) in Service information Center(http://svc.dwe.co.kr) 8.PARTS LIST JORDAN MIDDLE (DAEWOO , FR-330) NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 PART CODE 4019R54111 3012800501 4019R73571 4019R73581 4019R03208 3018100603 4019H23015 4017Z90590 3012906701 3016000600 3011721300 3012101300 3010302311 3010100201 3956127G50 4019H09030 3018101440 3016801102 3816100100 3010519030 3011317500 3012906300 3016004000 3011161200 401VA42021 3010530401 3013600020 3010008502 4017Z87570 4010C75252 3018913600 3012914500 3014558300 3017800305 3018301301 4010G56012 4017Z99112 4019R30133 4019R30143 4010R55212 4019R30824 4019R30812 3012309910 PART NAME ASS'Y CAB URT GUIDE DRN HEATER GLAS AS COVER DEFR HTR *T COVER DEFR HTR *U EVAPPORATOR AS SWITCH BIMTL AS FUSE TEMP AS FIXTURE FUSE TEMP HINGE *U AS SPECIAL BOLT SWITCH DR AS ADJ FOOT AS BASE COMP AS ABSORBER COMP COMPRESSOR SPECIAL WASHER SWITCH P RELAY AS DRYER AS RELAY BAND BOX POWER AS POWER CORD AS HINGE *M AS SPECIAL BOLT CASE VAPORI FAN MOTOR ASS ASSY R CONTL BOX LAMP AS DUCT M/F AS SHADE R LABEL DUCT LOUVER F AS HINGE *T AS COVER *T HI SHELF F THERMOSTAT CASE ICING CASE ICE CASE CHILD DOOR CHILD SHELF R COVER V/CASE CASE VEGTB ASSY F DOOR URT GASKET F DR AS DESCRIPTION HCFC-141B AL 150W GALVANIED GALVANIED 110V,220V PP P/O T3.2 ZN-COATING M6 X 20 1 BUTTON NR H=40 HPL27YE-5 , 240/50 SWRH 276THBYY, S220 HCFC 15G SK-5, T0.7, ZN-3-A R/C 350VAC/7MF CP-2PIN M6XL10 SWCH22A PP 3210DWNFF-2, 240/50 220-240V/50HZ 240V/15W HC-2 PC PP GPPS PFN-175D-01 PP(J-360) HC-2 GPPS GPPS GPPS GPPS GPPS HCFC-141B PVC-S -11- Q'TY 1 1 1 1 1 1 1 1 1 1 3 1 2 1 4 1 4 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 REMARK NO ACCUM NO 46 47 48 49 50 51 52 53 54 55 56 57 58 59 PART CODE 3012624000 3011610810 3019015700 3019015800 3012310010 3019016200 7002501611 3011165700 3019015900 3019016000 3019016100 3012624200 3011611110 PART NAME HANDLE F A DECO F HNDL AS POCKET F *T POCKET F *U ASSY R DOOR URT GASKET R DR AS POCKET SM SCREW MACHINE CASE EGG POCKET EGG POCKET MULT POCKET BOTL HANDLE R A DECO F HNDL AS DESCRIPTION ABS GPPS GPPS HCFC-141B PVC-S GPPS TRS 5X16 MFZN GPPS GPPS GPPS GPPS ABS -12- Q'TY 1 1 1 1 1 1 1 4 2 1 2 1 1 1 REMARK A TYPE A TYPE A TYPE A TYPE