1
Download Tanaka ECS-3351/B User's Manual
Transcript
Illustr ated P ar ts Man ual Illustra Par arts Manual Model Number: ECS-3351/B 32cc CHAINSAW P/N 40167 Rev 000 Date 4-02-08 Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212 www.tanakapowerequipment.com [email protected] PARTS INFORMATION ECS-3351 CYLINDER, PISTON, CRANKSHAFT & IGNITION • FIGURE 1 ITEM 1-1 1-2 1-6 1-6 1-7 1-9 1-10 1-11 1-11 1-12 1-13 1-16 1-17 1-18 1-31 1-34 1-35 1-35 1-66 1-75 PART NUMBER 15711666900 01801805200 0010174090 0010174091 99461050164 0170174020 04101730200 0300174090 0300174190 03701400200 03900000201 0460174080 99962091325 06810100200 99416040186 20501700200 1672152980 1672154080 75532050200 1780174080 DESCRIPTION CAP,SPARK PLUG PLUG,SPARK CYLINDER SET CYLINDER SET BOLT,HEX,5X16,S GASKET,CYLINDER RING,PISTON PISTON SET PISTON SET PIN,PISTON CIRCLIP,PISTON PIN CRANKSHAFT BEARING,NEEDLE,F-910 KEY,WOODRUFF,3X13X4.5 SCREW,WS,4X18 TAB,TERMINAL COIL,IGNITION COIL,IGNITION TUBE,CORD CORD,STOP www.tanakapowerequipment.com QTY 1 1 1 1 4 1 2 1 1 1 2 1 1 1 2 1 1 1 1 1 Page 1 COMMENTS ~U016860 U016861~ ~U016860 U016861~ ~U016860 U016861~ [email protected] PARTS INFORMATION ECS-3351 CRANKCASE / FLYWHEEL • FIGURE 2 ITEM 2-19 2-19 2-19 2-19 2-21 2-22 2-23 2-24 2-24 2-26 2-27 2-28 2-36 2-41 2-42 2-43 2-43 2-43 2-44 2-46 PART NUMBER 0710406321 0710406323 0710406324 0710406325 06600000200 99210070012 99201070011 1552152991 1552154090 7880174020 7900174020 99355040001 99461050204 0720174093 99966122240 0900174021 0900174021 0900174120 99961620106 99905250980 DESCRIPTION SHIM,CRANKSHAFT,0.1 SHIM,CRANKSHAFT,0.2 SHIM,CRANKSHAFT,0.3 SHIM,CRANKSHAFT,0.4 NUT,FLYWHEEL WASHER,S,7 WASHER,7 ROTOR,MAGNETO ROTOR,MAGNETO PAWL,STARTER SPRING,STARTER PAWL RING,STOP BOLT,HEX,HOLE,5X20,S CRANKCASE,ASS'Y SEAL,OIL,#12227 GASKET,CRANKCASE GASKET,CRANKCASE GASKET,CRANKCASE BEARING,BALL,#6201 ROLLER,NEEDLE,2.5X9.8 www.tanakapowerequipment.com QTY 1 1 1 1 1 1 1 1 1 2 2 2 4 1 2 1 1 1 2 1 Page 2 COMMENTS ~U016860 U016861~ ~R138860 ~Y212500 Y212501~ [email protected] PARTS INFORMATION ECS-3351 ENGINE CASE • FIGURE 3 ITEM 3-51 3-52 3-54 3-57 3-71 3-72 3-73 3-80 PART NUMBER 5603290090 56204060200 6450175090 99463050204 16201570900 18301300200 27401710800 0523290021 DESCRIPTION CASE,ENGINE VALVE,AIR VENT,B AIR VENT VALVE SET BOLT,HEX 5X20 SWITCH,STOP,ASS'Y NAME PLATE,SWITCH CORD,EARTH GROMMET,A www.tanakapowerequipment.com QTY 1 1 1 4 1 1 1 1 Page 3 COMMENTS [email protected] PARTS INFORMATION ECS-3351 AIR BOX, INTAKE, CARBURETOR • FIGURE 4 Units after serial number C110351~ www.tanakapowerequipment.com Page 4 [email protected] PARTS INFORMATION ECS-3351 AIR BOX, INTAKE, CARBURETOR • FIGURE 4 ITEM 4-1 4-2 4-3 4-4 4-5 4-7 4-7 4-8 4-9 4-10 4-10 4-11 4-12 4-14 4-15 4-15 4-16 4-16 4-17 4-17 4-19 4-20 4-21 4-21 4-36 4-39 4-45 4-46 PART NUMBER 3800631A200 0513290091 4460174020 4200174080 99414050451 99201050011 99200050011 70832350200 7003291820 4553290091 4553290G91 4020174020 99461050204 99200050011 4040174091 4040174G 90 39401700200 3940174G20 3950173020 3950174G20 99015030121 40901700200 4030174021 4030174G20 99075045144 1523290J21 1290173020 1913297020 DESCRIPTION BOLT,CLEANER COVER SET,CLEANER COVER FILTER,AIR-FOAM ELEMENT,CLEANER SCREW ,5X45/S W ASHER,5 WASHER,SMALL,5 SHIM,5.2X8X.80 VALVE,CHOKE,4.0 CARBURETOR SET CARBURETOR SET GASKET,CARBURETOR BOLT,HEX,HOLE,5X20,S WASHER,SMALL,5 SET,INSULATOR SET,INSULATOR VALVE,REED VALVE,REED HOLDER,REED VALVE HOLDER,REED VALVE SCREW ,3X12 RUBBER,CARB INSULATOR GASKET,INLET MANIFOLD GASKET, INLET MANIFOLD SCREW, TAPPING,4X14 COVER,CLEANER B COVER,SEAL GROMMET,IDLE www.tanakapowerequipment.com Page 5 QTY 1 1 1 1 2 1 1 2 1 1 1 1 2 2 1 1 1 1 1 1 2 1 1 1 3 1 1 1 COMMENTS Q211237~ ~R138860 R138861~ ~R138860 ~U016860 U016861~ ~C110350 C110351~ ~C110350 C110351~ ~C110350 C110351~ ~C110350 C110351~ Z116001~ [email protected] PARTS INFORMATION ECS-3351 MUFFLER • FIGURE 5 www.tanakapowerequipment.com Page 6 [email protected] PARTS INFORMATION ECS-3351 MUFFLER • FIGURE 5 ITEM PART NUMBER 5-26-1 99011050351 5-26 99011050401 5-27 99201050011 5-28-1 7040171090 5-28 7040174291 5-29-1 71701712800 5-29 7170174080 5-30-1 72401700200 5-30 7240174220 5-31 7390170920 5-32-1 71601700800 5-32 7160170980 5-33 73701700200 5-34-1 73201710200 5-34 7320174020 DESCRIPTION SCREW,5X35 SCREW,5X40 WASHER,5 SET,MUFFLER MUFFLER SET BODY,MUFFLER,B BODY,MUFFLER,B METAL,MUFFLER FITTING MUFFLER METAL GASKET,MUFFLER BODY,MUFFLER A BODY,MUFFLER A GASKET,MUFFLER ARRESTER,SPARK ARRESTER,SPARK www.tanakapowerequipment.com QTY 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 Page 7 COMMENTS ~U016860 U016861~ ~U016860 U016861~ ~U016860 U016861~ ~U016860 U016861~ U016861~ ~U016860 U016861~ ~U016860 U016861~ [email protected] PARTS INFORMATION ECS-3351 FUEL PIPE, OIL FILTER & CHOKE • FIGURE 6 ITEM 6-1 6-2 6-3 6-4 6-5 6-6 6-7 6-15 6-16 6-17 6-26 6-28 6-28 6-29 6-30 6-31 6-32 6-40 6-42 PART NUMBER 50532710200 68004019210 99201050011 48732712201 4863271090 8850174081 96401710200 99101060013 6780174020 6750404280 99967018000 19032710200 1903290G20 70732710200 70432710800 19132710200 99967020000 6423271990 6353271990 DESCRIPTION PIPE,OIL,B CLIP,7 WASHER,5 FILTER,OIL FILTER,ASS'Y WIRE,THROTTLE GROMMET,WIRE NUT,6 PIPE,RUBBER FILTER,FUEL O-RING,P18 CAP,ADJUSTER CAP,ADJUSTER GROMMET BUTTON,CHOKE GROMMET O-RING,P20 CAP,OIL TANK CAP,FUEL ASS'Y www.tanakapowerequipment.com QTY 1 3 1 1 1 1 1 1 1 1 1 1 ~U016860 1 U016861~ 1 1 1 1 1 1 Page 8 COMMENTS [email protected] PARTS INFORMATION ECS-3351 STARTER • FIGURE 7 ITEM 7-0 7-1 7-2 7-3 7-4 7-5 7-7 7-9 7-10 PART NUMBER 7560174090 99072050144 36832350200 7740174020 7830174020 7780174090 7850174020 1120174080 99072045204 DESCRIPTION STARTER,RECOIL,ASS'Y SCREW,TAPPING,5X14 WASHER,BRAKE SHAFT PULLEY,STARTER ROPE,STARTER,3X890 SPRING,RECOIL ASSY HANDLE,STARTER CASE,FAN SCREW,TAPPING,4.5X20 www.tanakapowerequipment.com QTY 1 1 1 1 1 1 1 1 4 Page 9 COMMENTS [email protected] PARTS INFORMATION ECS-3351 CARBURETOR • FIGURE 8 Units Prior to Serial Number U016860 0 www.tanakapowerequipment.com Page 10 [email protected] PARTS INFORMATION ECS-3351 CARBURETOR • FIGURE 8 ITEM 8-0 8-2 8-3 8-4 8-5 8-6 8-7 8-8 8-9 8-10 8-11 8-12 8-13 8-14 8-15 8-16 8-21 8-22 8-23 8-24 8-25 PART NUMBER 4553290091 57825007200 57525028200 51425001200 ~~~ ~~~ 46125027200 62325032200 47325001200 54625001200 47725013200 60525001200 47625004200 ~~~ ~~~ 60325001200 46325006200 46225016200 46025027200 48525040200 54825012200 DESCRIPTION CARBURETOR SET SCREEN,INLET BODY,PUMP SCREW,SET GASKET,PUMP DIAPHRAGM,PUMP SCREW,LOW ADJUST SPRING,ADJUST,HI/LOW HINGE,VALVE SCREW,SET,HINGE PIN SPRING,VALVE PIN,HINGE COVER,DIAPHRAGM DIAPHRAGM,METERING GASKET,DIAPHRAGM VALVE,NEEDLE SPRING,IDLE ADJUST SCREW,IDLE ADJUST SCREW,HIGH ADJUST SPRING,ADJUST,HIGH SCREW,SET www.tanakapowerequipment.com QTY COMMENTS 1 ~U016860 Includes gasket 1 1 1 1 ~ Included in 650.25001.910 Carb Kit 1 (not available individually) 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 Page 11 [email protected] PARTS INFORMATION ECS-3351 CARBURETOR • FIGURE 9 Units After Serial Number U016861 0 www.tanakapowerequipment.com Page 12 [email protected] PARTS INFORMATION ECS-3351 CARBURETOR • FIGURE 9 ITEM 9-0 9-2 9-4 9-5 9-6 9-9 9-10 9-12 9-13 9-14 9-15 9-21 9-22 9-25 9-30 9-31 9-32 PART NUMBER 4553290G91 57825007200 51425001200 ~~~ ~~~ 47325001200 54625001200 60525001200 47625004200 ~~~ ~~~ 46325006200 46225016200 54825012200 57525006200 6032501220 4772508020 DESCRIPTION CARBURETOR SET SCREEN,INLET SCREW,SET GASKET,PUMP DIAPHRAGM,PUMP HINGE,VALVE SCREW,SET,HINGE PIN PIN,HINGE COVER,DIAPHRAGM DIAPHRAGM,METERING GASKET,DIAPHRAGM SPRING,IDLE ADJUST SCREW,IDLE ADJUST SCREW,SET BODY,PUMP NEEDLE VALVE SPRING,VALVE www.tanakapowerequipment.com QTY COMMENTS 1 U016861~ Includes gasket 1 1 1 ~ Included in 650.25001.910 Carb Kit 1 (not available individually) 1 1 1 1 1 1 1 1 4 1 1 1 Page 13 [email protected] PARTS INFORMATION ECS-3351 OIL PUMP • FIGURE 10 ITEM 10-8 10-11 10-12 10-13 10-14 10-15 10-16 10-17 10-18 10-19 10-20 10-36 10-38 10-39 10-42 PART NUMBER 99416050141 0973290020 51532710200 0843290020 56701700201 1443290290 48832710210 50132710210 99967006000 0883277A91 99967006000 99072050144 70007105020 12532710200 99075045144 DESCRIPTION SCREW,5X14/WS COVER,OIL PUMP PIPE,OIL,B GEAR,SCREW SPONGE,AIR VENT PUMP,OIL GROMMET ADJUSTER,OIL PUMP O-RING,P-6 SET,OIL PUMP O-RING,P-6 SCREW,TAPPING,5X14 PIPE,VINYL CATCHER,CHAIN SCREW, TAPPING,4X14 www.tanakapowerequipment.com QTY 2 1 1 1 1 1 1 1 1 1 1 1 1 1 2 Page 14 COMMENTS [email protected] PARTS INFORMATION ECS-3351 CLUTCH & CHAIN BRAKE • FIGURE 11 12" Bar & Chain Combo = 844001 Bar = 120SDEA041 Chain = 91VG045X 14" Bar & Chain Combo = 844002 Bar = 140SDEA041 Chain = 91VG052X 16" Bar & Chain Combo = 844004 Bar = 160SDEA041 Chain = 91VG057X ITEM 11-2 11-4 11-5 11-6 11-7 11-21 11-22 11-23 11-24 11-25 11-31 11-32 11-37 11-46 11-49 11-52 11-54 11-55 11-56 11-57 11-58 11-59 11-60 11-61 11-62 11-63 11-64 PART NUMBER 12132530200 2870170081 99962101301 31032710200 35804050201 34501700200 34601700200 34201700200 3480170021 99274004143 99341040101 4663271021 5113290020 0403290190 3653290180 3753290021 3743290020 3863290180 99905300980 3793290180 3783290020 47010246200 0313290120 0393290180 3883290020 99341040151 11632710900 DESCRIPTION NUT,CLAMP,BAR CLUTCH BEARING,NEEDLE,101310 HOUSING,CLUTCH,3/8" WASHER,CLUTCH SHOE,CLUTCH BOSS,CLUTCH SPRING,CLUTCH PLATE,CLUTCH A RIVET SCREW,TAPPING,4X10 PLATE COLLAR,CRANKSHAFT CASE,SIDE ASS'Y HANDLE,BRAKE COVER,BRAKE LINK,BLACK SPRING,BRAKE METAL,BRAKE HOLDING BEARING,NEEDLE LINK,BRAKE BAND,BRAKE COLLAR COLLAR COVER,SIDE SPRING,BRAKE LEVER SCREW,4X15 BOLT,CHAIN TENSION,ASS'Y www.tanakapowerequipment.com Page 15 QTY 1 1 1 1 1 2 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 1 COMMENTS [email protected] PARTS INFORMATION ECS-3351 HANDLES • FIGURE 12 ITEM 12-1 12-5 12-6 12-8 12-9 12-10 12-11 12-16 12-17 12-18 12-20 12-26 12-27 12-28 12-32 12-33 12-36 12-41 12-42 12-43 12-46 12-49 PART NUMBER 99414050251 99178050010 99414050401 99200050011 27532710201 21932750200 99178050010 0113290180 72532161202 06632300201 06433225200 2573290020 0603290020 06132750201 99101040011 0103275081 99416040226 20932750801 26632750200 27632710201 99073050354 99073050354 DESCRIPTION SCREW,5X25 NUT,LOCK 5 SCREW,5X40/S WASHER,SMALL,5 COLLAR,DAMPER,A DAMPER,A NUT,LOCK 5 HANDLE,REAR B CAP,PUSH PIN SPRING,STOPPER PIN,PUSH LEVER,SAFETY LEVER,THROTTLE SPRING,THROTTLE LEVER NUT,4 HANDLE,REAR,A SCREW,WS,4X22 HANDLE,FRONT DAMPER,B COLLAR,DAMPER B SCREW,TAPPING,5X35 SCREW,TAPPING,5X35 www.tanakapowerequipment.com QTY 1 1 1 1 1 2 1 1 1 1 1 1 1 1 5 1 5 1 3 3 1 2 Page 16 COMMENTS [email protected] PARTS INFORMATION ECS-3351 DECALS & TOOLS • FIGURE 13 / 14 ITEM 13-1 13-5 13-6 PART NUMBER DESCRIPTION 01329325400 SPANNER,BOX,10X19 94332713200 COVER,BAR 081293297U DRIVER,MINUS,4x50 ITEM PART NUMBER 14-1 9503291920 14-2-1 9063290920 14-2 9063290G20 14-8 9073290920 14-9-1 9093290120 14-9 9093265320 14-10 9200650A20 DESCRIPTION DECAL,PRO FORCE DECAL,MODEL DECAL,ECS-3351/B DECAL,WARNING DECAL,SAFETY DECAL,CAUTION A DECAL,WARNING www.tanakapowerequipment.com Page 17 QTY 1 1 1 U016861~ COMMENTS QTY 1 1 1 1 1 1 1 COMMENTS ~U016860 U016861~ ~U016860 U016861~ [email protected]
