Download Poulan P4018 Parts Manual
Transcript
PARTS LIST NO. Replaces DATE 12/14/06 1 PPB4018 Note: Illustration may differ from actual model due to design changes 530165460 --- 9/15/06 TYPE 1,2 4 3 2 CHAIN SAW MODEL(s) R R R R WEED EATER PARTS LIST PARAMOUNT PARTS LIST POULAN PARTS LIST 530165460 6 WARNING All repairs, adjustments and maintenance 7 not described in the Operator’s Manual 26 personnel. 8 16 9 21 15 25 22 17 18 19 23 24 20 14 12 28 27 must be performed by qualified service 5 1 PAGE NO. 29 30 31 13 11 10 32 34 37 38 36 33 35 39 40 49 50 51 43 44 41 Clutch Washer Kit 46 45 47 42 53 54 52 55 48 Ref. Part No. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 530057893 530057908 530057891 530016080 530071888 530069216 530069247 530095649 530023877 530071945 530057905 530071945 530057907 530016419 530047192 530016064 530015922 530059635 530057911 530015127 530071966 Description Knob--Choke Spring--Ign. Switch Lever--Ign. Switch Screw Kit--Trigger/Lockout Kit--Fuel Line (Large) Kit--Fuel Line (Small) Assy--Fuel Pick Up Fitting--Fuel line Kit--Clutch Washer Assy--Clutch Drum 3/8” Kit--Clutch Washer Assy--Clutch Washer--Large Clutch Assy--Fuel Cap w/ret Screw Nut--”U” type speed Assy--Flywheel Shield--Heat Washer--Flywheel Kit--EPS Starter Pulley (Incl. 22,23,24,30) n = NEW PART NUMBER FOR THIS IPL Ref. 22. 23. 24. 25. 26. 27. 28. 29. 30. 31. 32. 33. 34. 35. 36. Part No. 530021179 530059677 530021180 530042095 545039603 530056402 530016080 530016432 530016392 530016134 530058786 530057236 530057897 530016416 530150165 37. 38. 39. 530071893 530016432 530016133 Description Screw--Shoulder Hub--EPS Spring--EPS Spring--Starter Housing--Fan Handle--Starter Kit--Rope Screw Screw Nut--Flywheel Assy--Oil Vent Assy--Oil Cap w/ret. Handguard Spring--Handguard Assy--Chassis (Incl. 5,6,7,8,9,15,16, 17,19,33,35,39) Kit--Chainbrake Screw Bolt--Bar K = REFER TO THE SERVICE REFERENCE Ref. Part No. 40. 41. 42. 530057910 530015917 545039803 43. 530069611 44. 45. 46. 47. 48. 530015826 530038593 952051338 952044689 530071945 49. 50. 51. 530016432 530057888 530071891 52. 53. 54. 55. 530057924 530016064 530057931 530037820 Description Plate--Bar Nut--Bar Assy--Clutch Cover (Incl. # 43) Kit--Bar Adjust (Incl. 44,45) Pin--Bar Adjust Retainer--Bar Adjust Accy--18” Chain Accy--18” Bar Kit--Clutch Washer (Incl. 10,12) Screw Handle--Front Kit--Oil Pump (Incl. 53,54,55) Assy--Oil Pick Up Screw Assy--Oil Pump Gear--Worm INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL) PARTS LIST NO. Replaces DATE 12/14/06 CHAIN SAW MODEL(s) R R R R WEED EATER PARTS LIST PARAMOUNT PARTS LIST POULAN PARTS LIST 530165460 PPB4018 Note: Illustration may differ from actual model due to design changes 530165460 --- 9/15/06 TYPE 1 1 2 PAGE NO. 2 8 9 4 10 5 11 12 3 6 13 14 15 16 7 39 17 38 37 18 19 36 21 20 22 35 34 23 WARNING 33 All repairs, adjustments and maintenance not 25 described in the Operator’s Manual must be 32 performed by qualified service personnel. 30 31 24 26 Engine Gasket Kit 40 Ref. 1. Part No. 530058837 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 530016153 530059006 530039238 530016432 530047442 530057943 530058687 530057925 530016425 530057892 -----530035590 530069247 530047721 530071889 13. 14. 15. 29 28 41 27 Description Ref. Shield--Cylinder (incl. #3) Screw Reflector--Tape Module -- Ignition Screw Strap--Ground Assy--Wire Harness Cover--Air Filter Filter--Air Screw Housing--Air Filter Carburetor Zama W--26 Kit--Fuel Line (Small) Bulb--Purge “snap--in” Kit--Carb. Adaptor ( Incl. # 16,34,37) n = NEW PART NUMBER FOR THIS IPL 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. 31. Part No. 530071894 952030150 530071884 530016136 530071887 530057942 530071894 530071886 530016338 530057885 530012537 530016417 530057941 530056363 530071883 530015697 Description Ref. Gasket--cyl. o--ring (kit) Accy--Spark Plug (RCJ--7Y) Kit--Cylinder (Incl. 25,33) Clip--High Tension Lead Kit--Muffler (Incl .21--23,24) Backplate--Muffler Gasket--Muffler (kit) Kit--Spark Arrestor Bolt--Muffler Insert--Left (black) Cyl. Assy--Crankshaft/Rod Bolt Cap--Crankcase Assy--Bearing/Seal Kit--Piston (Incl. 31,32) Retainer--Piston Pin 32. 33. 34. 35. 36. 37. 38. 39. 40. 530038729 530057886 530071894 530016426 530071894 530057926 530057909 530016101 530071894 41. 530031163 K = REFER TO THE SERVICE REFERENCE Part No. Description Ring--Piston Insert--Right (gray) Cyl. Seal--Adaptor (kit) Screw Gasket--Carb. (kit) Tube--Intake Wire--Throttle Nut--Carb. Kit--Gasket (Incl . 16,22,34,36) Scrench Not Shown 530165399 530059107 530058840 Manual--Operator Decal--Warning Decal--Start/Stop Inst. INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL) PARTS LIST NO. Replaces DATE 12/14/06 CHAIN SAW MODEL(s) R R R R WEED EATER PARTS LIST PARAMOUNT PARTS LIST POULAN PARTS LIST 530165460 PPB4018 Note: Illustration may differ from actual model due to design changes 530165460 --- 9/15/06 TYPE 2 1 3 PAGE NO. 2 8 9 4 10 5 11 12 3 6 13 14 15 16 7 39 17 38 37 18 19 36 21 20 22 35 34 23 WARNING 33 All repairs, adjustments and maintenance not 25 described in the Operator’s Manual must be 32 performed by qualified service personnel. 30 31 24 26 Engine Gasket Kit 40 Ref. 1. Part No. 530058837 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 530016153 530059006 530039238 530016432 530047442 530057943 530058687 530057925 530016425 530057892 -----530035590 530069247 530047721 530071889 13. 14. 15. 29 28 41 27 Description Ref. Shield--Cylinder (incl. #3) Screw Reflector--Tape Module -- Ignition Screw Strap--Ground Assy--Wire Harness Cover--Air Filter Filter--Air Screw Housing--Air Filter Carburetor Zama W--26 Kit--Fuel Line (Small) Bulb--Purge “snap--in” Kit--Carb. Adaptor ( Incl. # 16,34,37) n = NEW PART NUMBER FOR THIS IPL 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. 31. Part No. 530071894 952030150 530071884 530016136 545006007 530057942 530071894 530071886 530016338 530057885 530012537 530016417 530057941 530056363 530071883 530015697 Description Ref. Gasket--cyl. o--ring (kit) Accy--Spark Plug (RCJ--7Y) Kit--Cylinder (Incl. 25,33) Clip--High Tension Lead Kit--Muffler (Incl .21--23,24) Backplate--Muffler Gasket--Muffler (kit) Kit--Spark Arrestor Bolt--Muffler Insert--Left (black) Cyl. Assy--Crankshaft/Rod Bolt Cap--Crankcase Assy--Bearing/Seal Kit--Piston (Incl. 31,32) Retainer--Piston Pin 32. 33. 34. 35. 36. 37. 38. 39. 40. 530038729 530057886 530071894 530016426 530071894 530057926 530057909 530016101 530071894 41. 530031163 K = REFER TO THE SERVICE REFERENCE Part No. Description Ring--Piston Insert--Right (gray) Cyl. Seal--Adaptor (kit) Screw Gasket--Carb. (kit) Tube--Intake Wire--Throttle Nut--Carb. Kit--Gasket (Incl . 16,22,34,36) Scrench Not Shown n 545137231 530059107 530058840 Manual--Operator Decal--Warning Decal--Start/Stop Inst. INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)