1
Download Lochinvar RW 090-360 User's Manual
Transcript
RB-RW-09 Replacement Parts List RB 045-360 RW 090-360 Boilers — Water Heaters PARTS & SERVICE DEPARTMENT Nashville, Tennessee 615-889-8900 / Fax: 615-547-1000 www.Lochinvar.com 1 33 BASE 2 28 3 3 4 26 6 7 25 27 5 24 32 11 12 8 31 23 3 29 14 13 18 15 16 17 CONTROL PANEL ASSEMBLY 19 8 9 20 22 21 ITEM NO. PART NO. 1 1 1 1 1 --- DRH2934 DRH2935 DRH2936 DRH2937 DRH2938 DRH2929 DRH2930 2 2 2 2 2 2 2 2 3 3 3 3 3 3 3 3 3 6 7 7 7 7 7 7 7 7 23 23 23 23 23 23 23 23 FIB2909 FIB2910 FIB2911 FIB2912 FIB2926 FIB2927 FIB2928 FIB2929 FIB2917 FIB2901 FIB2902 FIB2903 FIB2904 FIB2918 FIB2919 FIB2920 FIB2921 FIB2900 FIB2905 FIB2906 FIB2907 FIB2908 FIB2922 FIB2923 FIB2924 FIB2925 FIB2913 FIB2914 FIB2915 FIB2916 FIB2930 FIB2931 FIB2932 FIB2933 10 DESCRIPTION MODEL NO. Flue Dampers FLUE DAMPER FLUE DAMPER FLUE DAMPER FLUE DAMPER FLUE DAMPER BELL INCREASER (NOT PICTURED) BELL REDUCER (NOT PICTURED) Loch-Heat® Tile LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, TOP LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, FILLER LOCH-HEAT TILE, SIDE LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, FRONT LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK NOTE: RB = Boiler / RW = Water Heater 2 045 075 - 135 180 & 199 225 & 270 315 & 360 045 045 045 075 & 090 135 180 225 270 315 360 045 045 075 & 090 135 180 225 270 315 360 ALL 045 075 & 090 135 180 225 270 315 360 045 075 & 090 135 180 225 270 315 360 ITEM NO. PART NO. 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 HEX3842 HEX3843 HEX3844 HEX3845 HEX3805 HEX3806 HEX3807 HEX3808 HEX3809 HEX3810 HEX3811 HEX3815 HEX3816 HEX3817 HEX3825 HEX3826 HEX3827 HEX3828 HEX3042 HEX3043 HEX3044 HEX3036 HEX3037 HEX3038 HEX3039 HEX3045 HEX3046 HEX3047 HEX3048 HEX3049 HEX3050 HEX3051 26 ARM3045PBF 8 9 10 16 16 19 19 19 19 19 20 24 24 28 33 --- RLY2042 RLY2023 TRF2004 HLC2904 HLC2905 TST2902 TST3920 TST3910 TST3911* TST2600 MSC2320 GTP2900 GTP3000 HLC2903 WRE2914 RLY2714 RLY29003 11 12 12 12 12 12 12 12 BNR2902 PLT2901 PLT2902 PLT2016 PLT2017 PLT2905 PLT2907 PLT2303 DESCRIPTION MODEL NO. Heat Exchangers HEAT EXCHANGER H HEAT EXCHANGER H HEAT EXCHANGER H HEAT EXCHANGER H HEAT EXCHANGER H (RW before serial F00) HEAT EXCHANGER H (RW before serial F00) HEAT EXCHANGER H (RW before serial F00) HEAT EXCHANGER H (RW before serial F00 & all RB) HEAT EXCHANGER H (RW before serial F00 & all RB) HEAT EXCHANGER H (RW before serial F00 & all RB) HEAT EXCHANGER H (RW before serial F00 & all RB) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00 & ALL RB) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00 & ALL RB) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00 & ALL RB) HEAT EXCHANGER CUPRO NICKEL H (RW before serial F00 & ALL RB) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) HEAT EXCHANGER CUPRO NICKEL HLW (after serial F00) Pumps PUMP, WTR. HEATER Controls RELAY, PUMP IGNITION MODULE TRANSFORMER 50V.A. ROLLOUT SWITCH ROLLOUT SWITCH OPERATOR OPERATOR LIMIT HI LIMIT (RW F-1 TO SERIAL NUMBER F966718) OVERHEAT, LIMIT MANUAL RESET (RW F-1 BEGINNING SERIAL NUMBER F966719) TERMINAL BOARD T & P GAUGE TEMPERATURE GAUGE SPILL SWITCH WIRING HARNESS, VENT DAMPER RELAY, ADJUSTABLE (F1's ONLY) [RW F-1 TO SERIAL NUMBER F966718] RELAY, 24V. (F1's ONLY) [RW F-1 TO SERIAL NUMBER F966718] Pilot & Burner Assemblies MAIN BURNER PILOT, BNR, NAT. F1 PILOT, BNR, LPG. F1 PILOT, BNR, NAT. FI PILOT, BNR, LP FI PILOT, BNR, NAT. F9/M9 PILOT, BNR, LPG. F9/M9 PILOT, BNR, NAT. F9/M9 3 RB45 RB75/90 RB135 RB180 RW75/90 RW135 RW180 199/225 270 315 360 RW75/90 RW135 RW180 199/225 270 315 360 RW75/90 RW135 RW180 RW199/225 RW270 RW315 RW360 RW75/90 RW135 RW180 RW199/225 RW270 RW315 RW360 ALL RW ALL RB ALL F9 ALL 045 - 180 225 & 270 ALL RB ALL RW ALL RW ALL RB/RW RW 90 - 270 (F-1) ALL ALL RB ALL RW 045 - 090 ALL RW 90 - 270 (F-1) RW 90 - 270 (F-1) ALL 045 - 090 045 - 090 135-270 135-270 135-270 ALL 045-090 ITEM NO. PART NO. 13 13 13 13 13 13 13 13 14 14 17 18 18 MAN2900 MAN2901 MAN2902 MAN2903 MAN2904 MAN2905 MAN2906 MAN2907 ORF2904 ORF2901 WRE2030 PLT2903 PLT2904 15 15 15 15 15 15 15 15 15 15 15 15 VAL2922 VAL2920 VAL4901 VAL2921 VAL2904 VAL2928 VAL2905 VAL2929 VAL2930 VAL2932 VAL2931 VAL2933 4 4 4 4 4 4 4 4 21 21 22 25 25 27 -29 29 29 29 29 29 29 29 31 32 -- JKR2059 JKR2060 JKR2061 JKR2062 JKR2179 JKR2180 JKR2181 JKR6182 WRE2911 WRE2912 WRE2915 RLV2005 RLV2006 TST2301 GLV3890 CFK3045 CFK3090 CFK3135 CFK3180 CFK3225 CFK3270 CFK3315 CFK3360 GKT2901 WTR3902 RLY2707 --------- LPK3900 LPK3901 LPK3903 LPK3904 TST2015 WTR2040 WTR2528 WTR2532 DESCRIPTION MODEL NO.5 Pilot & Buner Assemblies Con’t. GAS MANIFOLD Gas Valves GAS MANIFOLD GAS MANIFOLD GAS MANIFOLD GAS MANIFOLD GAS MANIFOLD GAS MANIFOLD GAS MANIFOLD ORIFICE, MAIN BNR. NAT. ORIFICE, MAIN BNR. LPG . IGNITION CABLE THERMOCOUPLE THERMOCOUPLE Gas Valves GAS VALVE, NAT. F1 GAS VALVE, NAT. F1 GAS VALVE, LPG. F1 GAS VALVE, LPG. F1 GAS VALVE, NAT. F9 GAS VALVE, NAT. F9 GAS VALVE, LPG. F9 GAS VALVE, LPG. F9 GAS VALVE, NAT. M9 GAS VALVE, LPG. M9 GAS VALVE, NAT. M9 GAS VALVE, LPG. M9 Miscellaneous V-BAFFLE V-BAFFLE V-BAFFLE V-BAFFLE V-BAFFLE V-BAFFLE V-BAFFLE V-BAFFLE WIRE HARNESS WIRE HARNESS JUMPER PLUG/VENT DAMPER RELIEF VALVE, PRESSURE ONLY RELIEF VALVE, T & P BULB WELL OUTLET TEE FOR ITEMS 24 & 25 (1.5" X .75" X 1.5") with 3/8" TAPPING COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT COMB. FLOOR KIT GASKET, FLANGE 1.5" FLANGE 1.5" PUMP DELAY Options (Not Pictured) NAT. TO LPG CONV. KIT, F1 NAT. TO LPG CONV. KIT, F1 NAT. TO LPG CONV. KIT, F9 NAT. TO LPG CONV. KIT, F9 MANUAL RESET HI LIMIT FLOW SWITCH LOW WATER CUT OFF PROBE FOR LWCO 4 045 075 & 090 135 180 225 270 315 360 ALL ALL ALL F9/M9 045-180 225-270 045-135 180-270 045-135 180-270 045-135 180-360 045-135 180-360 45-135 45-135 180-360 180-360 045 075 & 090 135 180 225 & 199 270 315 360 ALL F1 ALL F9 ALL RW & RB 315-360 ALL RB ALL RW ALL ALL RW 045 075 & 090 135 180 225 & 199 270 315 360 ALL RW ALL RW ALL RW 045-090 135-270 045-090 135-360 OPTIONAL OPTIONAL OPTIONAL OPTIONAL 9/03—Printed in U.S.A.
