1
Download Lochinvar COPPER-FIN CB--CW 987 - 2067 User's Manual
Transcript
CBXI-CWXI(E)-RP Rev B Replacement Parts List PARTS & SERVICE DEPARTMENT Nashville, Tennessee 615-889-8900 • Fax: 615-882-2918 [email protected] www.Lochinvar.com Copper-Fin ® Boilers — Water Heaters CB—CW 987 - 2067 52 21 18 19 50 37 33 36 35 53 41 48 46 40 42 51 32 38 34 1 17 15 16 49 47 43 6 CONTROL PANEL 5 10 11 9 4 8 13 7 14 12 22 HEAT EXCHANGER ASSEMBLY 25 23 29 26 31 30 39 24 28 27 44 GAS TRAIN ASSEMBLY 2 20 45 3 ITEM NO. PART NO. DESCRIPTION MODEL NO. BURNERS 1 Model 987 1257 1437 1797 2067 2 2 3 3 ORF20004 ORF20005 VAL2076 VAL2413 BNR3422 10 ea 13 ea 15 ea 19 ea 22 ea BNR3430 1 ea 1 ea 1 ea 1 ea 1 ea GAS TRAIN ASSEMBLIES ORIFICE, NAT ORIFICE, LP GAS VALVE, NAT GAS VALVE, LP PLEASE HAVE MODEL AND SERIAL NUMBER WHEN ORDERING PARTS CBXI-CWXI(E)-RP Rev B 2 of 4 ALL ALL ALL ALL ITEM NO. PART NO. DESCRIPTION MODEL NO. CONTRLS & GAUGES 4 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18 18 19 20 21 21 HLC2702 TST2314 TST5314 MSC2152 SWT2006 MSC2333 MSC2447 RLY20078 RLY2402 RLY2052 RLY2424 TRF2701 RLY2044 PLT3400 GKT2012 FAN2010 FAN20004 GKT2023 PRS2004 KIT3075 KIT3076 HIGH LIMIT, MANUAL RESET THERMOSTAT THERMOSTAT KNOB, FLUTED W/ SKIRT SWITCH, ON / OFF TERMINAL STRIP CIRCUIT BREAKER, 7 AMP BOARD, CONNECTOR IGNITION MODULE RELAY, PUMP RELAY, 24V TRANSFORMER, 150VA DISPLAY BOARD HOT SURFACE IGNITOR GASKET, IGNITER FAN ASSEMBLY FAN ASSEMBLY FAN GASKET GAS PRESSURE SWITCH, NAT PRESSURE SWITCH PRESSURE SWITCH 22 22 22 22 22 22 22 22 22 22 23 23 23 23 23 24 24 24 24 24 25 26 27 28 29 29 30 30 31 31 HEX30009 HEX30010 HEX30011 HEX30012 HEX30013 HEX30014 HEX30015 HEX30016 HEX30017 HEX30018 JKE20000 JKE20001 JKE20002 JKE20003 JKE20004 JKE60162 JKE60163 JKE60164 JKE60165 JKE60166 MSC20129 GKT20032 TST2050 TST2300 RLV2001 RLV2017 GTP2900 GTP3000 WTR2041 WTR2040 32 33 34 35 35 35 35 35 35 35 35 36 36 36 36 36 36 FIB20041 FIB20042 FIB20044 FIB20095 FIB20096 FIB20051 FIB20097 FIB20053 FIB20098 FIB20055 FIB20099 FIB20035 FIB20036 FIB20037 FIB20038 FIB20039 FIB20040 HEAT EXCHANGER, HLW HEAT EXCHANGER, HLW HEAT EXCHANGER, HLW HEAT EXCHANGER, HLW HEAT EXCHANGER, HLW HEAT EXCHANGER, H HEAT EXCHANGER, H HEAT EXCHANGER, H HEAT EXCHANGER, H HEAT EXCHANGER, H V-BAFFLE (11 REQ) V-BAFFLE (11 REQ) V-BAFFLE (11 REQ) V-BAFFLE (11 REQ) V-BAFFLE (11 REQ) FRAME RUNNER (2 REQ) FRAME RUNNER (2 REQ) FRAME RUNNER (2 REQ) FRAME RUNNER (2 REQ) FRAME RUNNER (2 REQ) RETAINER, V BAFFLE GASKET, HEAT SHIELD SENSOR, INLET BULBWELL, HIGH LIMIT RELIEF VALVE, PRESSURE ONLY RELIEF VALVE, TEMPERATURE & PRESSURE GAUGE, TEMPERATURE & PRESSURE GAUGE, TEMPERATURE FLOW SWITCH, OUTDOOR FLOW SWITCH, INDOOR LOCH-HEAT TILE LOCH-HEAT TILE, FRONT HEAD SIDE LOCH-HEAT TILE, REAR HEAD SIDE LOCH-HEAT TILE, DIVIDER LOCH-HEAT TILE, FRONT DOOR LOCH-HEAT TILE, FRONT DOOR LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, BACK RIGHT ALL CB CW ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL ALL 987 - 1257 1437 - 2067 ALL ALL 987, 1257, 1797, 2067 1437 HEAT EXCHANGERS PLEASE HAVE MODEL AND SERIAL NUMBER WHEN ORDERING PARTS NOTE: CB = BOILER, CW = WATER HEATER 3 of 4 CBXI-CWXI(E)-RP Rev B CW987 CW1257 CW1437 CW1797 CW2067 CB987 CB1257 CB1437 CB1797 CB2067 987 1257 1437 1797 2067 987 1257 1437 1797 2067 ALL ALL ALL ALL CB CW CB CW ALL ALL ALL ALL ALL 987 1257 1437 1437 1797 1797 2067 2067 987 1257 1437 1797 2067 1437-2067 ITEM NO. PART NO. DESCRIPTION MODEL NO. LOCH-HEAT TILE CONTINUED 37 37 37 37 37 38 38 38 38 38 38 38 38 38 38 38 38 38 38 38 38 FIB20000 FIB20002 FIB2257 FIB20004 FIB2259 FIB20043 FIB20045 FIB20046 FIB20047 FIB20045 FIB20048 FIB20059 FIB20045 FIB20060 FIB20061 FIB20045 FIB20062 FIB20063 FIB20045 FIB20064 FIB20065 INSULATION PAD, TOP INSULATION PAD, TOP INSULATION PAD, TOP INSULATION PAD, TOP INSULATION PAD, TOP LOCH-HEAT TILE, LEFT BOTTOM LOCH-HEAT TILE, MIDDLE BOTTOM LOCH-HEAT TILE, RIGHT BOTTOM LOCH-HEAT TILE, LEFT BOTTOM LOCH-HEAT TILE, MIDDLE BOTTOM (2) LOCH-HEAT TILE, RIGHT BOTTOM LOCH-HEAT TILE, LEFT BOTTOM LOCH-HEAT TILE, MIDDLE BOTTOM (2) LOCH-HEAT TILE, RIGHT BOTTOM LOCH-HEAT TILE, LEFT BOTTOM LOCH-HEAT TILE, MIDDLE BOTTOM (3) LOCH-HEAT TILE, RIGHT BOTTOM LOCH-HEAT TILE, LEFT BOTTOM LOCH-HEAT TILE, MIDDLE BOTTOM (3) LOCH-HEAT TILE, MIDDLE BOTTOM (1) LOCH-HEAT TILE, RIGHT BOTTOM 39 ARM3024PAB PUMP 987 1257 1437 1797 2067 987 987 987 1257 1257 1257 1437 1437 1437 1797 1797 1797 2067 2067 2067 2067 PUMPS CW MISCELLANEOUS 40 41 42 43 44 45 MSC3415 GKT2401 MSC20176 MSC2413 GKT2427 VAL2421 GKT2028 GKT3408 TUB2002 TUB2004 FIL2000 GKT2429 GKT30000 KIT40020 KIT40021 MSC2155 MSC2156 TST2032 TST2306 WTR30000 WTR30001 WTR2222 WTR20000 SIGHT GLASS AND GASKET KIT GASKET, SIGHT GLASS CONDUIT COVER SCREW, KNURLED HEAD GASKET, ESCUTCHEON, 3/4" VALVE, BALL GASKET, ESCUTCHEON, 2" GASKET, STRIP 45" TUBING, 3/16" X 5/16" GRAY TUBING, 1/8” ALUMINUM FILTER, 16 X 16 X 1 GASKET, BURNER GASKET, PVC 1/4 X 5/8 BLACK KIT, TANK SENSOR KIT, SYSTEM SENSOR TEE, 3/16 HOSE CAP, 3/16 TEE FITTING SENSOR, SYSTEM/TANK BULBWELL LOW WATER CUT-OFF, MANUAL RESET (OPTIONAL) LOW WATER CUT-OFF, AUTO RESET (OPTIONAL) LOW WATER CUT-OFF PROBE (OPTIONAL) LOW WATER CUT-OFF BOOT (OPTIONAL) 46 47 48 48 48 48 48 49 49 49 49 49 50 51 52 52 52 52 52 53 53 53 53 53 JKE30001 JKE60136 JKE30002 JKE30003 JKE30004 JKE30005 JKE30006 JKE60124 JKE60125 JKE60126 JKE60127 JKE60128 JKE60182 JKE60114 JKE60119 JKE60120 JKE60121 JKE60122 JKE60123 JKE30007 JKE30008 JKE30009 JKE30010 JKE30011 JACKET, OUTER FRONT UPPER MIDDLE JACKET, OUTER FRONT UPPER LEFT JACKET, OUTER FRONT UPPER RIGHT JACKET, OUTER FRONT UPPER RIGHT JACKET, OUTER FRONT UPPER RIGHT JACKET, OUTER FRONT UPPER RIGHT JACKET, OUTER FRONT UPPER RIGHT JACKET, OUTER FRONT LOWER JACKET, OUTER FRONT LOWER JACKET, OUTER FRONT LOWER JACKET, OUTER FRONT LOWER JACKET, OUTER FRONT LOWER JACKET, OUTER REAR HEAD JACKET, OUTER LEFT LOWER HEAD JACKET, OUTER TOP JACKET, OUTER TOP JACKET, OUTER TOP JACKET, OUTER TOP JACKET, OUTER TOP DOOR, COMBUSTION CHAMBER DOOR, COMBUSTION CHAMBER DOOR, COMBUSTION CHAMBER DOOR, COMBUSTION CHAMBER DOOR, COMBUSTION CHAMBER ALL ALL ALL ALL ALL CB ALL ALL ALL ALL ALL ALL ALL CW CB ALL ALL ALL ALL ALL ALL ALL ALL JACKET ASSEMBLIES ALL ALL 987 1257 1437 1797 2067 987 1257 1437 1797 2067 ALL ALL 987 1257 1437 1797 2067 987 1257 1437 1797 2067 PLEASE HAVE MODEL AND SERIAL NUMBER WHEN ORDERING PARTS NOTE: CB = BOILER, CW = WATER HEATER CBXI-CWXI(E)-RP Rev B 4 of 4 © -06/11 - Printed in U.S.A.
