1
Download KV-34FS12T
Transcript
更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com BA-5 CHASSIS SERVICE MANUAL MODEL COMMANDER DEST CHASSIS NO. KV-34FS12T RM-Y168 TAIWAN SCC-S42B-A KV-34FS12T RM-Y168 TRINITRON® COLOR TV 889 Front Page.p65 1 6/1/00, 10:21 AM 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com SPECIFICATIONS KV-34FS12T KV-34FS12T 110V, 60 Hz Power requirements Number of inputs/outputs Video 1) 3 S Video 2) 1 Audio 3) 3 Audio Out 4) 1 Y,PB, PR 5) 1 Speaker output(W) 5Wx2 Power Consumption(W) In use(Max) 165W In standby 5W Dimensions(W/H/D) (mm) 800 x 704 x 582 mm. (in) 31 1/2 x 27 3/4 x 23 in. Mass (kg) 74 kg. (lbs) 163 lbs. 2 oz. 1) 1 Vp-p 75 ohms unbalanced, sync negative 2) Y: 1 Vp-p 75 ohms unbalanced, sync negative C: 0.286 Vp-p (Burst signal), 75 ohms 3) 500mVrms (100% modulation), impedance: 47kilohms 4) More than 408 mVrms at the maximum volume setting (variable) 5) Y: 1.0 Vp-p, 75 ohms, sync negative; PB: 0.7 Vp-p, 75 ohms; More than 408 mVrms (fix) PR: Vp-p, 75 ohms Television system American TV standard/NTSC Channel coverage VHF:2-13/UHF:14-69/CATV:1-125 Visible screen size 32” picture measured diagonally Actual screen size 34” picture measured diagonally Antenna 75 ohm external antenna terminal for VHF/UHF Supplied accessories Remote Commander RM-Y168 Size AA (R6) batteries (2) Optional accessories Connecting cables: VMC-810S/820S, VMC-720M, YC-15V/30V, RK74A U/V mixer EAC-66 TV Stand: SU27FD3 Design and specifications are subject to change without notice. —2— 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com TABLE OF CONTENTS Section Title Page Warnings and Cautions ....................................................................................................................................... 4 Self-Diagnostic Function ...................................................................................................................................... 4 Safety Check-Out Instructions .............................................................................................................................. 7 1. GENERAL ........................................................................................................................................................... 8 2. DISASSEMBLY 2-1. Rear Cover Removal ............................................................................................................................... 2-2. Chassis Assembly Removal ..................................................................................................................... 2-3. Service Position ...................................................................................................................................... 2-4. Picture Tube Removal ............................................................................................................................. 14 14 14 15 SET-UP ADJUSTMENTS 3-1. Beam Landing ......................................................................................................................................... 3-2. Convergence .......................................................................................................................................... 3-3. Focus ...................................................................................................................................................... 3-4. Screen (G2) ............................................................................................................................................ 3-5. Method of Setting the Service Adjustment Mode ..................................................................................... 3-6. White Balance Adjustments .................................................................................................................... 16 17 18 19 19 19 3. 4. SAFETY RELATED ADJUSTMENTS R564 Confirmation Method (HV Hold-Down Confirmation) and Readjustments ................................. 20 4-1. 4-2. B+ Voltage Confirmation and Adjustment ................................................................................................ 20 5. CIRCUIT ADJUSTMENTS 5-1. Setting the Service Adjustment Mode ...................................................................................................... 5-2. Memory Write Confirmation Method ........................................................................................................ 5-3. Adjustment Buttons and Indicators .......................................................................................................... 5-4. MA Board Adjustments ............................................................................................................................ 22 22 22 26 DIAGRAMS 6-1. Block Diagram ......................................................................................................................................... 6-2. Circuit Board Location ............................................................................................................................. 6-3. Printed Wiring Boards and Schematic Diagrams ..................................................................................... • A Board .............................................................................................................................................. • MA Board ............................................................................................................................................ • HX Board ............................................................................................................................................ • CA Board ............................................................................................................................................ • K Board .............................................................................................................................................. • VA Board ............................................................................................................................................ • D Board .............................................................................................................................................. 31 37 37 38 45 49 51 52 54 55 6. 6-4. Semiconductors ...................................................................................................................................... 57 7. EXPLODED VIEW 7-1. Chassis ................................................................................................................................................... 58 8. ELECTRICAL PARTS LIST .............................................................................................................................. 59 —3— 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com WARNINGS AND CAUTIONS KV-34FS12T CAUTION ATTENTION!! SHORT CIRCUIT THE ANODE OF THE PICTURE TUBE AND THE ANODE CAP TO THE METAL CHASSIS, CRT SHIELD, OR CARBON PAINTED ON THE CRT, AFTER REMOVING THE ANODE. APRES AVOIR DECONNECTE LE CAP DE L'ANODE, COURT-CIRCUITER L'ANODE DU TUBE CATHODIQUE ET CELUI DE L'ANODE DU CAP AU CHASSIS METALLIQUE DE L'APPAREIL, OU AU COUCHE DE CARBONE PEINTE SUR LE TUBE CATHODIQUE OU AU BLINDAGE DU TUBE CATHODIQUE. WARNING!! ATTENTION!! AN ISOLATION TRANSFORMER SHOULD BE USED DURING ANY SERVICE TO AVOID POSSIBLE SHOCK HAZARD, BECAUSE OF LIVE CHASSIS. THE CHASSIS OF THIS RECEIVER IS DIRECTLY CONNECTED TO THE AC POWER LINE. AFIN D'EVITER TOUT RESQUE D'ELECTROCUTION PROVENANT D'UN CHÁSSIS SOUS TENSION, UN TRANSFORMATEUR D'ISOLEMENT DOIT ETRE UTILISÉ LORS DE TOUT DÉPANNAGE. LE CHÁSSIS DE CE RÉCEPTEUR EST DIRECTEMENT RACCORDÉ À L'ALIMENTATION SECTEUR. SAFETY-RELATED COMPONENT WARNING!! ATTENTION AUX COMPOSANTS RELATIFS A LA SECURITE!! COMPONENTS IDENTIFIED BY SHADING AND MARK ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS, AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER CRITICAL COMPONENTS ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED. LES COMPOSANTS IDENTIFIES PAR UNE TRAME ET PAR UNE MARQUE SUR LES SCHEMAS DE PRINCIPE, LES VUES EXPLOSEES ET LES LISTES DE PIECES SONT D'UNEIMPORTANCE CRITIQUE POUR LA SECURITE DU FONCTIONNEMENT. NE LES REMPLACER QUE PAR DES COMPOSANTS SONY DONT LE NUMERO DE PIECE EST INDIQUE DANS LE PRESENT MANUEL OU DANS DES SUPPLEMENTS PUBLIES PAR SONY. LES REGLAGES DE CIRCUIT DONT L'IMPORTANCE EST CRITIQUE POUR LA SECURITE DU FONCTIONNEMENT SONT IDENTIFIES DANS LE PRESENT MANUEL. SUIVRE CES PROCEDURES LORS DE CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU LORSQU'UN MAUVAIS FONTIONNEMENT SUSPECTE. SELF-DIAGNOSTIC FUNCTION The units in this manual contain a self-diagnostic function. If an error occurs, the STANDBY/TIMER LED will automatically begin to flash. The number of times the LED flashes translates to a probable source of the problem. A definition of the STANDBY/TIMER LED flash indicators is listed in the instruction manual for the user’s knowledge and reference. If an error symptom cannot be reproduced, the Remote Commander can be used to review the failure occurrence data stored in memory to reveal past problems and how often these problems occur. Diagnostic Test Indicators When an error occurs, the STANDBY/TIMER LED will flash a set number of times to indicate the possible cause of the problem. If there is more than one error, the LED will identify the first of the problem areas. Results for all of the following diagnostic items are displayed on screen. No error has occurred if the screen displays a “0”. —4— 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Display of Standby/Timer LED Flash Count 2 times 4 times 5 times LED ON 0.3 sec. LED OFF 0.3 sec. STANDBY/TIMER LED LED OFF 3 sec. Diagnostic Item Flash Count* +B overcurrent I-Prot IK 2 times 4 times 5 times *One flash count is not used for self-diagnostic. Stopping the Standby/Timer LED Flash Turn off the power switch on the TV main unit or unplug the power cord from the outlet to stop the STANDBY/TIMER LAMP from flashing. Self-Diagnostic Screen Display For errors with symptoms such as “power sometimes shuts off” or “screen sometimes goes out” that cannot be confirmed, it is possible to bring up past occurrences of failure on the screen for confirmation. To Bring Up Screen Test In standby mode, press buttons on the Remote Commander sequentially, in rapid succession, as shown below: Display Channel 5 Sound volume Power ON Note that this differs from entering the service mode (sound volume + ). Self-Diagnostic Screen Display SELF DIAGNOSTIC 2: 000 3: N/A 4: 000 5: 001 101: N/A Numeral 0 means that no fault was detected. Numeral 1 means a fault was detected one time only. —5— 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Handling of Self-Diagnostic Screen Display Since the diagnostic results displayed on the screen are not automatically cleared, always check the self-diagnostic screen during repairs. When you have completed the repairs, clear the result display to “0”. Unless the result display is cleared to “0”, the self-diagnostic function will not be able to detect subsequent faults after completion of the repairs. Clearing the Result Display To clear the result display to “0”, press buttons on the Remote Commander sequentially when the diagnostic screen is displayed, as shown below: Channel 8 ENTER Quitting the Self-Diagnostic Screen To quit the entire self-diagnostic screen, turn off the power switch on the Remote Commander or the main unit. Self-Diagnostic Circuit +B overcurrent (OCP) Occurs when an overcurrent on the +B (135V) line is detected by pin 33 of IC301 (MA Board). If the voltage of pin 33 of IC301 (MA Board) is less than 1V when V.SYNC is more than seven verticals in a period, the unit will automatically turn off. I-Prot Occurs when an absence of the vertical deflection pulse is detected by pin 5 of IC001 (MA Board). Power supply will shut down when waveform interval exceeds 2 seconds. IK If the RGB levels* do not balance within 2 seconds after the power is turned on, this error will be detected by IC301 (MA Board). TV will stay on, but there will be no picture. *(Refers to the RGB levels of the AKB detection Ref pulse that detects 1K). —6— 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Leakage Test The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. Check the area of your repair for unsoldered or poorly soldered connections. Check the entire board surface for solder splashes and bridges. 2. Check the interboard wiring to ensure that no wires are “pinched” or touching high-wattage resistors. 3. Check that all control knobs, shields, covers, ground straps, and mounting hardware have been replaced. Be absolutely certain that you have replaced all the insulators. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers' instructions to use these instructions. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 4. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. 5. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement. 6. Check the line cords for cracks and abrasion. Recommend the replacement of any such line cord to the customer. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low voltage scale. The Simpson’s 250 and Sanwa SH-63TRD are examples of passive VOMs that are suitable. Nearly all battery-operated digital multimeters that have a 2 VAC range are suitable (see Figure A). How to Find a Good Earth Ground 7. Check the B+ and HV to see if they are specified values. Make sure your instruments are accurate; be suspicious of your HV meter if sets always have low HV. 8. Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. A cold-water pipe is a guaranteed earth ground; the coverplate retaining screw on most AC outlet boxes is also at earth ground. If the retaining screw is to be used as your earth ground, verify that it is at ground by measuring the resistance between it and a cold-water pipe with an ohmmeter. The reading should be zero ohms. If a cold-water pipe is not accessible, connect a 60- to 100-watt trouble- light (not a neon lamp) between the hot side of the receptacle and the retaining screw. Try both slots, if necessary, to locate the hot side on the line; the lamp should light at normal brilliance if the screw is at ground potential (see Figure B). Trouble Light AC Outlet Box Ohmmeter Cold-water Pipe Figure A. Using an AC voltmeter to check AC leakage. Figure B. Checking for earth ground. —7— The instructions mentioned here are partial abstracts from the Operating Instruction Manual. The page numbers shown reflect those of the Operating Instruction Manual. Operating Instructions Cable Box Connections Connecting Your TV Some pay cable TV systems to use scrambled or encoded signals that require a cable box to view all channels. Read this chapter before setting up your TV for the first time. This section covers basic connections in addition to any optional equipment you may be connecting. Cable Box Cable (Rear of TV) VHF/UHF Basic Connections IN OUT Cable Box TV with indoor or outdoor antenna, or CATV cable Depending on the cable available in your home, choose one of the connections below: 1 Connect the coaxial cable from your cable service to the IN jack on your cable box. 2 Connect a coaxial cable (not supplied) from the OUT jack on your cable box to the VHF/UHF jack on your TV. —8— If you will be controlling all channel selection through your cable box, you should consider using the Channel Fix feature, (see page 26). Cable Box and Cable For this set up, you can switch between scramble channels (through your cable box), and normal (CATV) channels by using the button. Cable Box (Rear of TV) AUX IN OUT TO CONVERTER 75-ohm coaxial cable (not supplied) (Signal) VHF/UHF If you are connecting to an indoor or outdoor antenna, you may need to adjust the orientation of the antenna for best reception. 3 4 CATV cable (unscrambled channels) If you are connecting a cable box through the AUX input and would like to switch between the AUX and normal (CATV) input, you should consider using the Channel Fix feature, (see page 26). Your Sony remote control can be programmed to operate your cable box, (see page 36). When using PIP, you cannot view the AUX input in the window picture. KV-34FS12T 更多难得资料请到江南家电维修论坛免费下载！ SECTION 1 GENERAL http://bbs.520101.com 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com Connecting Your TV Connecting Additional Equipment Operating Instructions TV and Cable Box TV and VCR Cable Box Rear of TV 1 Rear of TV From cable 2 VCR 2 1 From cable/ antenna 1 Connect the coaxial cable from your cable service to the IN jack on your cable box. 2 Connect a coaxial cable (not supplied) from the OUT jack on your cable box to the VHF/UHF jack on the TV. 3 (Optional connection) —9— 1 Connect the coaxial cable from your TV antenna or cable service to the IN jack on your VCR. 2 Connect a coaxial cable (not supplied) from the OUT jack on your VCR to the VHF/UHF jack on the TV. To watch video programs from your VCR, tune your TV to channel 3 or 4 (as set on the rear of your VCR). To view channels from your cable box, tune your TV to channel 3 or 4 (as set on the rear panel of your cable box) and use the cable box’s remote control to change channels. If you will be controlling all channel selection through your cable box, you should consider using the Channel Fix feature, (see page 26). (Optional connection) 3 If your VCR is equipped with video outputs, you can get better picture quality by connecting A/V cables (not supplied) from AUDIO and VIDEO OUT on your VCR to AUDIO/VIDEO IN on your TV. For optimum picture quality, use S VIDEO instead of the yellow A/V cable. S VIDEO does not provide sound, the audio cables must still be connected. You can use the inputs. button to switch between the VHF/UHF and VIDEO 6 KV-34FS12T 5 Connecting Your TV TV, Cable box, and Cable Operating Instructions TV, VCR, and Cable box Rear of TV KV-27FS16, KV-27FV16, KV-32FS16, KV-29FV16 only For this set up, you can switch between scrambled channels (through your cable box) and normal (CATV) channels by pressing . Rear of TV (KV-27FV16 only) 3 VCR Cable Box 2 Cable box From Cable 1 4 (Optional connection) — 10 — Cable When using PIP, the AUX input cannot be viewed in the window picture. 1 Connect the coaxial cable from your cable service to the IN jack on your cable box. 2 Connect a coaxial cable (not supplied) from the OUT jack on your cable box to the IN jack on your VCR. 3 Connect a coaxial cable (not supplied) from the OUT jack on your VCR to the VHF/UHF jack on the TV. If you will be controlling all channel selection through your cable box, you should consider using the Channel Fix feature, (see page 26). (Optional connection) 4 7 8 If your VCR is equipped with video outputs, you can get better picture quality by connecting A/V cables (not supplied) from AUDIO and VIDEO OUT on your VCR to AUDIO/VIDEO IN on your TV. For optimum picture quality, use S VIDEO instead of the yellow A/V cable. S VIDEO does not provide sound, the audio cables must still be connected. You can use the inputs. button to switch between the VHF/UHF and VIDEO KV-34FS12T 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com Connecting Your TV TV and Satellite Receiver Operating Instructions TV, Satellite Receiver, and VCR Satellite antenna cable Rear of TV 2 1 From cable/ antenna Rear of TV 4 VCR SATELLITE IN 1 VHF/UHF AUDIO R AUDIO L VIDEO Satellite receiver 2 AUDIO R AUDIO L VIDEO IN OUT LINE OUT VHF/UHF LINE IN IN SATELLITE IN VHF/UHF AUDIO R AUDIO L VIDEO Satellite antenna cable From cable/ antenna Satellite receiver IN OUT LINE OUT OUT 3 LINE OUT 5 3 — 11 — 1 Connect the cable from your satellite antenna to SATELLITE IN on your satellite receiver. 2 Connect the coaxial cable from your cable or antenna to the VHF/UHF jack on your TV. 3 Using A/V cables, connect AUDIO and VIDEO OUT on your satellite receiver to AUDIO and VIDEO IN on your TV. For optimum picture quality, use S VIDEO instead of the yellow A/V cable. S VIDEO does not provide sound, the audio cables must still be connected. You can use the receiver inputs. 1 Connect the cable from your satellite antenna to SATELLITE IN on your satellite receiver. 2 Connect the coaxial cable from your cable or antenna to the IN jack on your VCR. 3 Using a coaxial cable, connect the OUT jack on your VCR to the VHF/UHF jack on your TV. 4 Using A/V cables, connect AUDIO and VIDEO OUT on your satellite receiver to AUDIO and VIDEO IN on your VCR. 5 Using A/V cables, connect AUDIO and VIDEO OUT on your VCR to AUDIO and VIDEO IN on your TV. button to switch between the VHF/UHF and satellite 10 KV-34FS12T 9 To view from the satellite receiver or VCR, select the video input to which your satellite receiver or VCR is connected by pressing on the remote control. Using the Remote Control and Basic Functions Using the Remote Control and Basic Functions SLEEP Turns the TV off automatically in approximately 15, 30, 45, 60, 90, or 120 minutes. Cancel by pressing until SLEEP OFF appears. MTS/SAP Cycles through the Multi-channel TV Sound (MTS) options: Stereo, Mono, and Auto-SAP (Second Audio Programming). DISPLAY Press once to show current time, (if set) and channel number. This section shows you how to use the more advanced buttons on the remote control and how to use the on-screen menus. Using the Remote Control Button Description POWER Press when you want to turn connected equipment on and off. FUNCTION Press when you want to control connected equipment with your remote control. MUTING — 12 — / Cycles through available Steady Sound settings, (see page 23). Instantly turns off the sound. Press again or press to restore sound. JUMP Alternates between the last two channels selected with the 0 9 buttons. GUIDE Brings up the custom guide of your satellite receiver. SYSTEM OFF Powers off all Sony equipment at once, (may not work with older equipment). MENU Displays the on-screen menu. Press again to exit the menu at any time. TV/VIDEO Cycles through available video inputs. RESET Press to return to factory settings while in an on-screen menu. ANT Press to change the VHF/UHF input to the AUX input (KV-27FS16, KV-27FV16, KV-32FS16 only). CODE SET Use to program your remote control to operate connected video equipment, (see page 36). TV/VTR Press when you are finished using a VCR and you want to switch to the TV input. Your VCR power will remain on. For information on Picture in Picture (PIP) operation buttons, see page 17. If you lost your remote control, see page 40. Moves the cursor in the onscreen menus. Press the arrow buttons to move the cursor. Press the center button to select or access an option. 14 PICTURE MODE Cycles through the available Video Mode settings. The remote control shown (RM-Y171) is for KV-27FV16. Your remote control may not look like the one illustrated. 15 KV-34FS12T 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com Other Information Troubleshooting If you are having a problem with your TV, try the suggestions below. If the problem persists, contact your nearest Sony dealer. — 13 — Poor or no picture, good sound Good picture, no sound No color No signal Dotted lines or stripes Double images or ghosts Make sure the power cord is plugged in. If red light is flashing on the front of your TV for more than a few minutes, disconnect and reconnect the power cord to restore the TV. If the problem continues, call your local service center. Check the TV/VIDEO settings: when watching TV, set to TV; when watching video equipment, set to VIDEO (page 14). Make sure the batteries have been inserted correctly into the remote control (page 2). Try another channel, it could be station trouble. Cable stations don’t seem to work Remote control does not operate The TV needs to be cleaned Adjust Picture in the Video menu (page 22). Adjust Brightness in the Video menu (page 22). Check the antenna and/or cable connections (page 3). Lost password for Parental Control Press so that MUTING disappears from the screen (page 14). Check your Audio settings. Your TV may be set to Auto-SAP (page 24). You lost your remote control Make sure Cable is set to OFF in the Channel Setup menu (page 25). Perform Auto Program to add channels that are not presently in the memory (page 16). Make sure Cable is set to ON in the Channel Setup menu (page 25). Perform Auto Program to add channels that are not presently in the memory (page 16). Batteries could be weak. Replace them (page 2). Move the TV 3-4 feet away from fluorescent lights. Clean the TV with a soft dry cloth. Never use strong solvents such as thinner or benzine, which might damage the finish of the cabinet. In the password screen, enter the following master password: 4357. After using the master password, you must create a new password, it cannot be used to unlock currently blocked channels. You can use the front A/V panel controls to access the menu. Press to open the menu. Use the or buttons on the front A/V panel instead of the F or buttons on the remote control. Use the button on the front A/V panel instead of the G, g, and buttons on the remote control. Press again when the setting or adjustment is complete. Contact your nearest Sony dealer to order a replacement. Adjust Color in the Video menu (page 22). Check the Cable setting in the Channel Setup menu (page 25). Check the antenna and/or cable connections (page 3). Make sure the channel selected is currently broadcasting. Cannot access other menus when using the Basic Menu Adjust the antenna. Move the TV away from other electronic equipment. Some electronic equipment can create electrical noise, which can interfere with TV reception. If you use the button to close the Basic menu, only the Basic menu appears when you press again. To have access to the other menus, use the button to select Advance Menu (page 35). F Cannot receive higher number channels (UHF) when using an antenna F No picture, no sound Operating Instructions If, after reading these Operating Instructions, you have additional questions related to the use of your Sony television, please call our Direct Response Center at 1-800-222-SONY (7669) (U.S. residents only) or (416) 499-SONY (7669) (Canadian residents only). Check your outdoor antenna or call your cable service. 40 KV-34FS12T 39 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T SECTION 2 DISASSEMBLY 2-1. REAR COVER REMOVAL 4 Screws (+BVTP 4x16) 4 Screws (+BVTP 4x16) Rear Cover 4 Screws (+BVTP 4x16) 4 Screws (+BVTP 3x16) 2-3. SERVICE POSITION 2-2. CHASSIS ASSEMBLY REMOVAL CA Board VA Board Claw Chassis Assembly D Board MA Board — 14 — A Board 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com 2-4. PICTURE TUBE REMOVAL 1 WARNING: BEFORE REMOVING THE ANODE CAP 10 2 9 High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap. 8 7 3 6 5 Coated Earth Ground Strap 4 1. Discharge the anode of the CRT and remove the anode cap. 6. Loosen the deflection yoke fixing screw and remove. 2. Unplug all interconnecting leads from the deflection yoke, neck assembly, degaussing coils and CRT grounding strap. 7. Place the set with the CRT face down on a cushion and remove the degaussing coil holders. 3. Remove the CA Board from the CRT. 8. Remove the degaussing coils. 4. Remove the chassis assembly. 9. Remove the CRT grounding strap and spring tension devices. Loosen the neck assembly fixing screw and remove. 10. Unscrew the four CRT fixing screws [located on each CRT corner] and remove the CRT [Take care not to handle the CRT by the neck]. 5. ANODE CAP REMOVAL WARNING: High voltage remains in the CRT even after the power is disconnected. To avoid electrical shock, discharge the CRT before attempting to remove the anode cap. Short between anode and coated earth ground strap of CRT. NOTE: After removing the anode, short circuit the anode of the picture tube and the anode cap to either the metal chassis, CRT shield, or carbon painted on the CRT. REMOVAL PROCEDURES c b a Anode Button 1 Turn up one side of the rubber cap in the direction indicated by arrow a . 2 Use your thumb to pull the rubber cap firmly in the direction indicated by arrow b . HOW TO HANDLE AN ANODE CAP 1 Do not use sharp objects which may cause damage to the surface of the anode cap. 2 To avoid damaging the anode cap, do not squeeze the rubber covering too hard. A material fitting called a shatter-hook terminal is built into the rubber. 3 Do not force turn the foot of the rubber cover. This may cause the shatter-hook terminal to protrude and damage the rubber. — 15 — 3 When one side of the rubber cap separates from the anode button, the anode cap can be removed by turning the rubber cap and pulling it in the direction of arrow c . 更多难得资料请到江南家电维修论坛免费下载！ SECTION 3 http://bbs.520101.com SET-UP ADJUSTMENTS KV-34FS12T The following adjustments should be made when a complete realignment is required or when a new picture tube is installed. Perform the adjustments in order as follows: 1. Beam Landing 2. Convergence 3. Focus 4. Screen (G2) 5. White Balance These adjustments should be performed with rated power supply voltage unless otherwise noted. Set the controls as follows unless otherwise noted: Note: Test equipment required: VIDEO MODE: STANDARD PICTURE control: ................ Normal BRIGHTNESS control: ........ Normal • • • • Color Bar Pattern Generator Degausser DC Power Supply Digital Multimeter 5. Move the deflection yoke forward and adjust so that the entire screen becomes green. 3-1. BEAM LANDING Before beginning adjustment procedure: 1. Degauss the entire screen. 2. Feed in the white pattern signal. Adjustment Procedure 1. Input a raster signal with the pattern generator. 2. Loosen the deflection yoke mounting screw and set the purity control to the center as shown below. Purity Control 6. Switch over the raster signal to red and blue and confirm the condition. 7. When the position of the deflection yoke is determined, tighten it with the deflection yoke mounting screw. 8. If landing at the corner is not right, adjust by using the disk magnets. Purity control corrects this area 3. Turn the raster signal of the pattern generator to green. Disk magnets 4. Move the deflection yoke backward and adjust the purity control so that green is in the center and red and blue are at the sides evenly. a b c d or rotatable disk magnets correct these areas (a-d) Deflection yoke positioning corrects these areas Blue Red b d Green a c — 16 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com 3-2. CONVERGENCE Horizontal Static Convergence Before starting convergence adjustments: If the blue dot does not converge with the red and green dots, perform the following: 1. Perform FOCUS, V.LIN AND V.SIZE adjustments. 1. Move BMC magnet (a) to correct insufficient H. Static convergence. 2. Set BRIGHTNESS control to minimum. 3. Feed in dot pattern. 2. Rotate BMC magnet (b) to correct insufficient V. Static convergence. Vertical Static Convergence 3. After adjusting the BMC magnet, repeat Beam Landing Adjustment. 1. Adjust V.STAT magnet to converge red, green and blue dots in the center of the screen (Vertical movement adjust V.STAT RV701 to converge). V.STAT BMC MAGNET PURITY 2. Tilt the V.STAT magnet and adjust static convergence to open or close the V.STAT magnet. b When the V.STAT magnet is moved in the direction of arrows a and b, red, green, and blue dots move as shown below: (1) a b a b b B B G G R R (2) a R G B B G R BMC magnet b Dynamic Convergence Adjustment Before performing this adjustment, perform Horizontal and Vertical Static Convergence Adjustment. (3) b a 1. Slightly loosen deflection yoke screw. B R 2. Remove deflection yoke spacers. G G b B R 3. Move the deflection yoke for best convergence as shown on the following page. — 17 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T 4. Adjust XCV core to balance X axis. 5. Adjust YCH VR to balance Y axis. R B G R B G G B RG B R R G B B G R 6. Adjust vertical red and blue convergence with V.TILT (TLV VR). Note: Perform adjustments 3-6 while tracking items 1 and 2. B G R R G B Screen-Corner Convergence 1. Affix a permalloy assembly corresponding to the misconverged areas. B R G B R G G R B GR B a b a 4. Tighten the deflection yoke screw. a-d: screen-corner 5. Install the deflection yoke spacers. misconvergence c TLH Plate Adjustment 1. Input crosshatch pattern. d 2. Adjust PICTURE QUALITY to standard, PICTURE and BRIGHTNESS to 50%, and OTHER to standard. 3. Adjust the Horizontal Convergence of red and blue dots by tilting the TLH plate on the deflection yoke. c 3-3. FOCUS 1. Adjust FOCUS control for best picture. RV701 TLH Plate V.STAT CA Board VA Board XCV YCH TLV (TLV) Focus (FV) Screen (G2) BR (R)(B) RB (B)(R) b TLH+ TLH- — 18 — d 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com 3-4. SCREEN (G2) 3-6. WHITE BALANCE ADJUSTMENTS 1. Input a dots pattern. 1. Input an entire white signal with burst. 2. Set the PICTURE and BRIGHTNESS controls at minimum and COLOR control at normal. 2. Set to Service Adjustment Mode. 3. Adjust SBRT, GCUT, BCUT in service mode with an oscilloscope as shown below so that voltages on the red, green, and blue cathodes are 170 ± 2.0 VDC. 4. Adjust with SBRT if necessary. 3. Set the PICTURE and BRIGHTNESS to minimum. 5. Select GCUT and BCUT with 6. Adjust with and and . for the best white balance. 7. Set PICTURE and BRIGHTNESS to maximum. 8. Select GDRV and BDRV with 9. Adjust with and 3-5. METHOD OF SETTING THE SERVICE ADJUSTMENT MODE Service Mode Procedure 1. Standby mode (power off). 2. Press Display Sound volume + Channel 5 Power on the Remote Commander (press each button within a second). Service Adjustment Mode In 1. The CRT displays the item being adjusted. 2. Press or on the Remote Commander to select the item. 3. Press data. or on the Remote Commander to change the 4. Press then to save into the memory. Service Adjustment Mode Memory Turn set off then on to exit service adjustment mode. Display Item Item Data Mode Category service Signal Type defl hsiz vchp 16 write ntsc 00000000 00000000 — 19 — . for the best white balance. 10. To write into memory, press 4. Observe the screen and adjust SCREEN (G2) VR in FBT to obtain the faintly visible background of dot signal. and then . 更多难得资料请到江南家电维修论坛免费下载！ SECTION 4 http://bbs.520101.com SAFETY RELATED ADJUSTMENTS KV-34FS12T 4-1. R564 CONFIRMATION METHOD (HV HOLD-DOWN CONFIRMATION) AND READJUSTMENTS Hold-Down Readjustment If the setting indicated in Step 2 of Hold-Down Operation Confirmation cannot be met, readjustment should be performed by altering the resistance value of R564 component marked with . The following adjustments should always be performed when replacing the following components which are marked with on the schematic diagram: Part Replaced ( ) Adjustment ( DY, T505, CRT, IC501, C507, HV HOLD-DOWN C520, C505, C509, C515, T504, (R564) T505 FBT ammeter 3.0 mA DC range ) ABL + A - IABL T503, C551, L510, C546, C537, C547, D517, D518, D519, R560, R561, R562, R563, R565, R566, R567, R525........................A Board 4-2. B+ VOLTAGE CONFIRMATION AND ADJUSTMENT IC301.............................MA Board Note: The following adjustments should always be performed when replacing the following components, which are marked with on the schematic diagram on the A Board. Preparation Before Confirmation 1. Using a Variac, apply AC input voltage: 120 ± 2 VAC. A BOARD: 2. Turn the POWER switch ON. 3. Input a white signal and set the PICTURE and BRIGHTNESS controls to maximum. IC601, PH601 1. Using a Variac, apply AC input voltage: 130 + 2.0/-0.0 VAC. 2. Input a monoscope pattern. 4. Confirm that the voltage between C546 (+) or TP503 and ground is more than 23.0 VDC. 3. Set the PICTURE and BRIGHTNESS controls to minimum. 4. Confirm that the voltage of A Board TP-600 is <136.5 VDC. Hold-Down Operation Confirmation 5. If Step 3 is not satisfied, replace the components listed above, then repeat Steps 1–3. 1. Connect the current meter between Pin 11 of the FBT (T505) and the PWB land where Pin 11 would normally attach (See Figure 1 on the next page.) 2. Input a dot signal and set PICTURE and BRIGHTNESS to minimum: IABL = 2175 + 100/- 325 µA. 3. Confirm the voltage of A Board TP-600 is 135 ± 1.5 VDC. 4. Connect the digital voltmeter and the DC power supply via diode 1SS119 to C546 (+) and ground (See Figure 1 on the next page.) 5. Increase the DC power voltage gradually until the picture blanks out. 6. Turn DC power source off immediately. 7. Read the digital voltmeter indication (standard < 27.24 + 0.0/- 0.1 VDC) . 8. Input a white signal and set PICTURE and BRIGHTNESS to maximum: IABL = 2175 + 100/- 325 µA . 9. Repeat Steps 4 to 7. — 20 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com POWER SUPPLY DIGITAL MULTIMETER + – + – 1SS119 R564 C546 1 9 R454 R438 R449 JR503 C448 + R450 C530 R529 R567 R565 R445 IC501 R522 Q411 R525 8 Q503 D620 18 10 R225 R403 5 D235 R563 C546 R573 R531 R447 4 H.PROT D234 C213 R218 R407 C542 Q205 Q206 E B E R659 C659 6 4 D232 6 2 R539 D506 2 R506 C510 R518 7 T504 L509 R231 D233 D520 R511 C525 C550 D518 R540 C543 C511 L505 H.PULSE R232 C523 1 R615 C518 -13V IC502 C629 L502 D236 D510 FB502 C524 R601 R226 R227 C211 C541 R541 R514 L602 Q201 1 R527 D507 R532 C519 R537 R561 D514 D517 D616 FB503 TH501 C532 R558 R559 R543 C517 200V H.DRIVE 6 R507 C624 1 FB610 L501 CN502 JR502 R557 D511 C513 T503 Q505 C552 CN511 C611 HEATER 4 1 C654 T505 FBT R554 D516 R555 6 E CN506 B T502 R535 5 JUMPER-ID 135V 5 1 Q501 B 4 R505 R801 3 7 CN515 V DY - C555 C504 Q502 R516 V DY + T505 H DY - H-OUT R503 R804 C503 ABL11 H DY + R504 R515 1 C505 C509 C536 R803 H DY - 2 H DY + CN501 +B C 1 R545 C515 CN504 D521 R533 L510 C554 R546 R568 R502 L507 R547 C551 R534 R553 AMMETER 3mA dc range A TP600 + – Figure 1 — 21 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com SECTION 5 KV-34FS12T CIRCUIT ADJUSTMENTS ELECTRICAL ADJUSTMENTS BY REMOTE COMMANDER Use the Remote Commander (RM-Y168) to perform the circuit adjustments in this section. NOTE: Test Equipment Required: • • • • Pattern generator Frequency counter Digital multimeter Audio oscillator 5-1. SETTING THE SERVICE ADJUSTMENT MODE 5-2. MEMORY WRITE CONFIRMATION METHOD 1. Standby mode (power off). 1. After adjustment, remove the power plug from the AC outlet, then plug it in again. Sound volume + Channel 5 2. Press Display Power 2. Turn the power switch ON and set to service mode. on the Remote Commander (press each button within a second). 3. Call the adjusted items again to confirm they were adjusted. 5-3. ADJUSTMENT BUTTONS AND INDICATORS Service Adjustment Mode On 1. The CRT displays the item being adjusted. MUTING 2. Press or on the Remote Commander to select an item. 3. Press or on the Remote Commander to change the data. 4. Press then defl hsiz 6 00000000 1. Press then initialize. service defl 16 8 00000000 VOLUME Display Item Item Data hsiz 16 write ntsc vchp ENTER 4 on the Remote Commander to Mode Category Signal Type 1 write ntsc vchp 3 5 Display Item Item Data Mode Category service DISPLAY to save into the memory. Service Adjustment Mode Memory Signal Type POWER 00000000 00000000 Carry out Step 1 when adjusting IDs 0–6 and when replacing and adjusting IC003. 2. Turn set off then on to exit Service Adjustment Mode. — 22 — RM-Y168 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T Adjustment Items http://bbs.520101.com Reg # ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 HSIZ HPOS VBOW VANG VTRP HTRP TROT PAMP UPIN LPIN VSIZ VPOS VLIN SCOR VZOM EHT ASP SCRL HBLK LBLK RBLK HDW EWDC LVLN UVLN INTL G2SW G2LV HOSC VSS HSS HMSK VTMS CDMD AFC FIFR VBLK REFP JPSW RDRV GDRV BDRV RCUT GCUT BCUT SCON SHUE SCOL SBRT CHUE CCOL UOFS VOFS RON GON BON AXPL AXNT CBPF CTRP COFF KOFF SSHP SHPF PREL Y-DC GAMM ABLM VTH YDEL NCOL FSC K-ID GDOF BDOF GCOF BCOF SYSC VENH FUNCTION RANGE Horizontal Size Adjustment Horizontal Position Adjustment Vertical Line Bowing Adj. Vertical Line Bowing Slant Adj. TRAPEZIUM Horiz. Trapezoid Tilt Correction Horizontal PIN distortion Adj. Upper PIN Distortion Adj. Lower PIN Distortion Adj. Vertical Size Adjustment Vertical Position Adj. Vertical lineality Adj. Vertical "S" Correction Adjustment 16:9 CRT Z Mode on/off Vertical High-Voltage Compensation Aspect Ratio control 16:9 CRT Z Mode Trans. Scroll Horizontal Blanking on/off Left Blanking Adjustment Rigth Blanking Adjustment Horizontal Drive Pulse Width "Parabola" EW, D.C. Adjustment Lower Screen BTM Vertical Line Adj. Upper Screen BTM Vertical Line Adj. INTERLACE Horizontal VCO Oscillation Freq. Vertical Sync Slice Level Horizontal Sync Slice Level For Macro Vision Select Signal VTIM Pin Vertical Count Down Mode Switching AFC Loop Gain Switching Field Frequency VBLKW REFP JUMPSW R Output Drive control G Output Drive control B Output Drive control R Output Cutoff control G Output Cutoff control B Output Cutoff control SUB CONT Sub HUE adjustment Sub COLOR adjustment Sub BRIGHTNESS adjustment SUB HUE (Except YUV SUB COLOR (Except YUV) YUV U OFFSET YUV V OFFSET R Output on/off G Output on/off B Output on/off Axis PAL Axis NTSC Chroma BPF on/off Y TRAP FILTER on/off Color On/off Set Color Killer Sub SHARPNESS SHARPNESS Circuit Fo Pre-Shoot/ Over-Shoot DC transmition Ratio Switching Gamma Correction ABL Mode Switch ABL CD VHT Switching Y Delay Time Control No Color ID FSC Out on/off Killer ID Control on/off Color System Vertical Enhancement 0-63 0-63 0-15 0-15 0-31 0-15 0-63 0-63 0-63 0-63 0-63 0-63 0-15 0-15 0-1 0-15 0-63 0-63 0-1 0-15 0-15 0-1 0-15 0-15 0-3 0-1 0-7 0-15 0-1 0-1 0-1 0-3 0-3 0-3 0-3 0-3 0-1 0-1 0-63 0-63 0-63 0-15 0-15 0-15 0-15 0-31 0-31 0-31 0-31 0-31 0-15 0-15 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-15 0-3 0-1 0-3 0-3 0-1 0-1 0-15 0-1 0-1 0-1 0-31 0-31 0-31 0-31 0-7 0-7 — 23 — FIX DATA VIDEO NTSC RF 18 13 9 3 18 6 31 27 41 39 51 42 5 8 0 5 47 31 1 13 8 1 0 0 0 0 0 0 12 0 0 0 0 3 0 3 0 0 MENU 41 25 25 31 15 12 8 16 16 7 7 7 1 1 1 0 1 1 1 0 0 5 Palette 1 Palette Palette 1 1 7 1 1 0 3 16 16 7 4 Palette 0 AVERAGE DATA 22 22 9 7 17 2 31 27 38 35 51 39 4 8 0 5 47 31 1 13 8 1 0 0 0 0 0 0 7 0 0 0 0 3 0 3 0 0 0 40 42 31 31 12 15 11 16 18 16 6 4 7 7 1 1 1 0 1 1 1 0 0 5 2 0 2 2 1 1 7 1 1 0 3 16 16 7 4 3 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Reg # 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 ITEM PDSO CK VNL HPK HPKO CORE TRAP CHTR CBPF ENHO NMRD YAPS CLKS NSTD MSS KILS ADIN EXCS CPP HDP CDL DYCR DYGN DCCR DCGN YNRL CNRL WSC VTRH VTRR LDSR VAPG VAPI TEST YPFT YPFG CC3N SELD D2GN YHCR YPFC SHT MVT OTT CL2D CLKG HPLL BPLL FSCF PLLS KILR HSSL VSSL BGPS BGPW ADCK NDSW PFRN PRVS PCON PUCO PVCO PHUE PKIL PSEP PHIM PSUB PBGS PDL0 PDL1 PBRT PVP1 PUP1 PVP2 PUP2 PVP3 PUP3 PACS PSDL FUNCTION PDS OFF CK VNL HPK HPK OFF CORE TRAP CH TRAP CBPF ENHOFF NMRD YAPS CLKS NSTDS MSS KILS ADIN EXCSS CPP HDP CDL DYCOR DYGAIN DCCOR DCGAIN YNRLIM CNRLIM WSC VTRH VTRR LDSR VAPGAIN VAPINV TEST YPFT YPFG CC3N SELD D2GAIN YHCOR YPFCOR SHT MVT OTT CL2D CLKGGT HPLLFS BPLLFS FSCFG PLLS KILR HSSL VSSL BGPS BGPW ADCLKS NSDSW FREE_RUN RVS CONTRAST U-DAC V-DAC KILLER EXT_SC_SEL BG_START Y_OFFSET SET_ACC SYNC_DELAY RANGE 0-1 0-1 0-15 0-1 0-1 0-3 0-1 0-1 0-1 0-1 0-3 0-3 0-3 0-3 0-3 0-3 0-1 0-3 0-3 0-7 0-7 0-15 0-15 0-15 0-15 0-3 0-3 0-3 0-3 0-3 0-3 0-7 0-31 0-1 0-3 0-15 0-1 0-1 0-7 0-3 0-1 0-3 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-15 0-15 0-15 0-15 0-15 0-3 0-1 0-1 0-1 0-127 0-127 0-127 0-31 0.1 0-3 0-1 0-1 0-63 0-15 0-15 0-31 0-1 0-3 — 24 — FIX DATA 0 0 3 0 Palette 2 1 0 1 0 0 3 0 0 0 1 0 1 2 4 4 2 10 3 6 1 1 1 1 1 2 3 6 0 3 7 0 1 4 0 0 0 0 0 1 0 1 0 0 1 3 12 8 4 10 3 1 0 0 45 10 18 15 0 2 0 0 14 6 13 25 0 0 0 0 0 0 1 0 VIDEO NTSC RF AVERAGE DATA 0 0 3 0 0 1 1 0 1 0 0 3 0 0 0 1 0 1 2 4 4 2 10 3 6 1 1 1 1 1 2 3 6 0 3 7 0 1 5 0 0 0 0 0 1 0 1 0 0 1 3 12 8 4 10 3 1 0 0 45 16 24 15 0 2 0 0 14 6 13 25 0 0 0 0 0 0 1 0 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Reg # 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 ITEM PDCO PCGA PAAF PSU2 PCVF PBIT PAFC PACC PBUR PEVE PINW PINR PREF PARE PAVE PFRA PPAL PHPO PVPO PHTI PHAJ PBGY PCRO PPAR PHPF PFSC PVCH PVON PVLN PVSB PVLV SBAL SBAS STRE BBEL BBEH BBE AUX DISP HCLW HCHG ID0 ID1 ID2 ID3 ID4 ID5 ID6 FUNCTION C_GAIN BITSEL AFCBITSEL ACC_LEVEL BURST_CLK EVENUPRA INV_WFF INV_REF RFF_FIX AUTO_REF AVERAGE FREE_RUN_ADJ SUB_PALM_JUDGE HT ADJ BGY CROSS_SEL PALRY HPFOFF FSC_OUTPUT SET_VCHIP VCHIP_ONLY LINE_NUM STB_DLY L_LEVEL Sub Balance Sub Bass Sub Trebble BBE Low BBE High BBE SRS, Simulated O.S.D Display position Horizontal Count Lower limit Horizontal Count High limit FIX RANGE DATA 0-3 0-1 0-1 0-1 0-1 0-1 0-1 0-63 0-1 0-1 0-1 0-1 0-1 0-1 0-1 0-15 0-255 0-31 0-31 0-15 0-15 0-15 0-1 0-63 0-1 0-1 0-1 0-1 0-31 0-255 0-255 0-15 0-7 0-7 0-15 0-15 0-1 0-3 0-130 0-255 0-255 0-255 0-255 0-255 0-255 0-255 0-255 0-255 0 1 0 0 0 0 0 22 0 0 0 0 0 1 0 0 0 9 22 5 1 0 0 2 0 0 0 1 17 64 130 5 0 3 0 0 0 0 20 16 64 VIDEO NTSC 0 1 0 0 0 0 0 22 0 0 0 0 0 1 0 0 0 6 22 9 1 0 0 2 0 0 0 1 17 64 130 5 0 3 0 0 0 0 34 16 64 9 31 207 130 137 19 0 16 64 Notes: Mode No. 1–206 show the order that each adjustment mode may be selected while in service mode. Data Range shows the range of possible Signal Type settings for each adjustment mode. Initial Data shows the standard settings for each adjustment mode. Chip Version — 25 — AVERAGE DATA RF Function service ntsc id’s ID Number id5 Data 19 00010011 M37280MK-00SP VERB.O 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T 5-4. MA BOARD ADJUSTMENTS Display Position Adjustment (DISP) 1. Input a color-bar signal. H. Frequency (Free Run) Check 2. Set to Service Adjustment Mode. 1. Input a TV mode (RF) with no signal. 3. Select DISP with 2. Connect a frequency counter to base of Q501 (TP-500 H. DRIVE) on the A Board. and . and 4. Adjust values of DISP with to the center. 3. Check H. Frequency for 15735 ± 200 Hz to adjust characters then 5. Write to memory by pressing . 6. Check to see if the text is displayed on the screen. V. Frequency (Free Run) Check 1. Select video 1 with no signal input. Mode 2. Set the conditions for a standard setting. service micro 3. Connect the frequency counter to TP-508 (V OUT) or (V DY+) and ground on the A Board . CN501pin 4. Check that V. Frequency shows 60 ± 4 Hz. Signal Type Item Data Display Item Category disp 48 ntsc vchp 8(0) 8(0) Drive (RDRV) 1. Input a color-bar signal and set the level to 75%. Sub Bright Adjustment (SBRT) 2. In Standard mode, set PICTURE to maximum and COLOR to minimum. 1. Input a monoscope signal. 3. Activate the Service Adjustment Mode. 3. Set the PICTURE and BRIGHTNESS to minimum. and 4. Set both GON and BON items. Using the following values. Leave RON set to “1”. Mode Category service Signal Type video Item Data Display Item rdrv ; set each to 2. Activate the Service Adjustment Mode. 4. Select the SBRT item with and 6. Press then . and 5. Adjust the values of SBRT with visible crosshatch. to obtain a faintly to save into the memory. 26 Sub Hue, Sub Color Adjustment (CHUE, CCOL) ntsc vchp 1. Input a color-bar signal. 8(0) 8(0) 2. Activate the Service Adjustment Mode. R ON: G ON: B ON: ON (1) OFF (0) OFF (0) 3. Connect an oscilloscope probe to CA Board, CN705 Pin . 4. Select the CHUE and CCOL item with 5. Connect an oscilloscope probe to CA Board, J701 Pin 12 (KR) (Red Out) . 6. Select RDRV with and . 7. Adjust the value of RDRV with and for 92.5 ± 3 VDC. R ON: G ON: B ON: ON ON ON (1) (1) (1) 10. Press then V4 to save into the memory. 1. Input a crosshatch signal. 2. Activate the Service Adjustment Mode. 3. Select the VSIZ item with MAX CENTER then 7. Press V2 V3 V. Size Adjustment (VSIZ) 9. Reset Picture and Color to normal values: PICTURE: COLOR: . 6. While showing the CCOL item, adjust the waveform with and until the first and fourth bars show the same level (V1 = V4 < 0.1 Vp-p). V1 8. Reset GON and BON values to “1”. and 5. While showing the CHUE item, adjust the waveform with and until the second and third bars show the same level (V2 = V3 < 0.1 Vp-p). 4. Adjust value of VPOS with center. to save into the memory. 5. Press — 26 — then and and . for the best vertical to save into the memory. 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com V LINEARITY (VLIN) V CORRECTION (SCOR) V. Center Adjustment (VPOS) Perform this adjustment after performing H. Frequency (Free Run) Check. 1. Input a crosshatch signal. PIN AMP (PAMP) 2. Activate the Service Adjustment Mode. 3. Select the VPOS item with and . 4. Adjust value of VPOS with center. and for the best vertical 5. Press HORIZONTAL TRAPEZOID (HTRP) then to save into the memory. V. Angle (VANG), V. Bow (VBOW), Upper pin (UPIN) and Low Pin (LPIN) Adjustments H. Center Adjustment (HPOS) 1. Input a crosshatch signal. Perform this adjustment after performing H. Frequency (Free Run) Check. 2. Activate the Service Adjustment Mode. 3. Select VANG, VBOW, UPIN, and LPIN with 1. Input a crosshatch signal. 4. Adjust with 2. Activate the Service Adjustment Mode. and 3. Select the HPOS item with 5. Press then and . for the best picture. then 5. Press . and 4. Adjust the value of HPOS with horizontal center. and to save into the memory. for the best V ANGLE (VANG) to save into the memory. V BOW (VBOW) H. Size Adjustment (HSIZ) 1. Input a monoscope signal. UPPER PIN (UPIN) 2. Activate the Service Adjustment Mode. 3. Select HSIZ with 4. Adjust with 5. Press and and . for the best horizontal size. then LOW PIN (LPIN) to save into the memory. Service Adjustment Mode Memory V. Linearity (VLIN), V. Correction (SCOR), Pin Amp (PAMP), and Horizontal Trapezoid (HTRP) Adjustments 1. Change the value of the DCOL item to “1”. 2. After completing all adjustments, press then 1. Input a crosshatch signal. Read From Memory 2. Activate the Service Adjustment Mode. 3. Select VLIN, SCOR, PAMP, and HTRP with with 4. Adjust with 5. Press and then and Mode . for the best horizontal size. Category service Signal Type to save into the memory. defl Item Data Display Item vbow 7 Green 0 ntsc Red vchp — 27 — 00000000 00000000 ENTER . 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T NOTES: — 28 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com NOTES: — 29 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T NOTES: — 30 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com SECTION 6 DIAGRAMS 6.1 BLOCK DIAGRAM KV-34FS12T CN301 Y Y-TO-YUV 1 CR 2 J206 Y,PR,PB PB INPUT 3 CB 4 GND A AUDIO PR (POWER SUPPLY) (DEFLECTION) L 9V J203 L INPUT AUDIO R J202 L INPUT MON-R 2 3 VAR/FIX-R VAR/FIX-R 3 4 VAR/FIX-L VAR/FIX-L 4 5 OUT-L OUT-L 5 6 OUT-R OUT-R 6 9V 9V 7 8 MUTE BUFFER Q430,431 OUT-A Q432,433 LINEA LINEB OUT-B 9V 8 GND GND 9 YUV-L YUV-L 9 IN5 10 YUV-R YUV-R 10 IN5A 11 V3-L V3-L 11 IN4 12 V3-R V3-R 12 IN4A 13 V1-L V1-L 13 IN2 14 V1-R V1-R 14 IN2A 15 MUTE MUTE 15 NC NC 16 17 TV-L TV-L 17 IN1 18 TV-R TV-R 18 IN1A 19 V2-R V2-R 19 IN3A 20 V2-L V2-L 20 IN3 16 VIDEO FRONT A/V MON-R 7 VIDEO REAR A/V 1 2 SCL SDA 1 SCL 2 GND 3 SDA B QP DRIVE OUTPUT MON-L 1 AUDIO MON-L V MOD R REAR VAR/FIX CN450 1 9V DRIVE (MTS) 2 J402 CN460 (AUDIO) R V MOD (TUNER/IF) INPUT 4 L AUDIO 3 J205 YCBCR AUDIO CN402 AUDIO DQP DRIVE PROCESSOR Q808 CN904 IC404 QP AUDIO +B R C 9V S 3 Y 4 1 2 1 135V 135V 1 2 NC NC 2 3 GND GND 3 4 GND GND 4 5 9V 9V 5 6 HP HP 6 7 VD+ VD+ 7 CN515 +B CN902 Q807 9V HP QP DRIVE HP Q812 IC803 (AUDIO PROCESSOR) Q811 ( CN506 BUFFER V 1 DF CN802 DF VELOCITY MODULATION ) CN901 AMP Q801 CN504 1 SW BUFFER Q810 Q809 9V DF-COMP IC802 CN801 L R SW V MOD BUFFER Q803,804 V MOD IC801 Q802 Q805,806 1 QP DRIVE 2 9V DRIVE 3 V MOD 4 V MOD +B 5 VM VM 5 4 9V 9V 4 3 E E 3 2 NC NC 2 1 +B +B 1 9V VM OUT VM DRIVE Q903 Q905 Q901 Q904 Q906 Q902 1 QP- QP- 8 2 QP- QP- 7 3 QP+ QP+ 6 4 QP+ QP+ 5 5 E E 4 6 E E 3 7 VM VM 2 8 VM VM 1 VM 9 STBY 7.5V TU101 9V 9V 30V 30V 5V 5V VM QP H OUT (CONVERGENCE) CN800 J201 S-VIDEO QP SPSW 8 VM 7 STBY 7.5V 6 5 DATA GND I-PROT 4 DGC 3 RELAY 2 HP 1 MUTE CN2008 C CLOCK DE-EM OUT MODE 7 O-SAP ST LED 5 DET-OUT 4 MAIN1 3 MAIN2 AFT OUT 2 RF AGC 1 I-SAP I-STEREN CN2007 D AFT AGC MUTE AGC SET9V Q101 R OUT VOL-CTRL VOL-CTRL Q410 Q411 STANDBY CIRCUIT 1 T604 SRT :STAND BY D623 VC1 IN2 VC2 IN1 AUDIO AMP +B IC401 3 OUT1+ OUT3OUT4+ 4 5 9 6 8 SET9V T501 1 STBY DRIVE Q607 4 2 H DRIVE 3 Q501 H OUT 6 HV 1 Q502 1 18 5 16 200V OCP T603 T505 FBT 2 Q505 4 15 3 17 V HOLD 2 NC 2 1 CNTRL 13 LOW B V OUT LOW B IC502 RECT S LOW B 8 12 7 11 9 REF AUDIO AUDIO RECT VCC Q506,507 IN-1 2 1 3 V1 3 GND 2 Y1 1 C1 1 SPK R+ H Q604 IC2001 STBY +5V +B PIN DRIVE PIN OUT CN4001 T503 FUNCTION 4 1 3 Q504 Q601,602 Q603 (KEY) 5 T504 IC604 9V REG IC603 MENU-SW 5 KEY-SW 6 STBY +5V 7 V2(VIDEO2) 8 GND 6 V DY+ 5 V DY- 4 H DY- 3 H DY- 2 H DY+ 1 H DY+ CN2001 G SWITCHES 1 2 3 POWER-SW GND KEY-SW CN2003 POWER-SW GND KEY-SW 1 2 3 1 TP508 2 TP507 3 4 LOW B IR(SENSOR) S2008 Q503 SW POWER-SW 3 S2007 7 8 10 D605 D4SB60L-F AC RECT 9 IC602 LED-TIMER 2 4 1 5V + SPL 5 1 5V REG SPK LSPK L+ RELAY DRIVE 6 DF 10 LOW B SPK R- ABL 0 ERROR AMP F 11 R645 10k 2 4 CN2005 OUT VDR601 3 1 4 4 2 5 SET9V 0 IN+2 IR DETECT PH600 PHOTOCOUPLER 30V G2 D2001 F601 SET5V 6 CN406 4P T602 CN602 SCL 9 SW OUT2 IC501 14 OCP/FB IN+1 OUT1 D VIN SDAT 8 FV DRIVE+ IC601 CN604 DGC V3 9 4 +B DRIVE- CONVERTER RY601 DGC RELAY 3 VD- PIP-L 3 8 +B RECT DGC E MONITOR 10 2 7 Q609 VD+ CN2006 + SPR 4 1 4 7 Q608 RY602 RELAY AC POWER DGC EW D626 SWITCH DGC DRIVER 5 Q605 30V 2 ABL 1 SET5V 3 GND 6 3 OUT2- C636 NC HD 7 2 Q606 DGC I-HLDWN 8 CONVERTER PROTECT CN603 SET9V 10 9 D622 D4SB60L-F AC RECT AC IN O-MONO 6 L OUT DGC 8 SAP LED VIDEO DGC GND 9 F MONO V DY(+) 9V TP 506 CN502 V DY(-) H DY(-) H DY(+) 6 HEATER BA5-889-BD CN501 H — 31 — — 32 — — 33 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com DIG COMB STBY+5V FILTER IC002 CN002 FOR JIG DAT 3 GND 2 CLK 1 B-CLK 1 B-DAT 2 B-INT 3 GND 4 9 VM 8 STBY 7.5V C CN003 7 GND 6 I-PROT 5 DGC 4 RELAY 3 HP 2 MUTE 1 (Y/C/J) BUFFER Q001 IO-BCLKN CN302 I-RESET IO-BDAT I-BINT CVBS4IN BUFFER SPSW SCL AIN CN309 B (TUNING CONTROL) IC302 RESET COUT IC003 YOUT STBY+5V REG CKIN STBY+7.5V MEMORY SDA KV-34FS12T HSYNCH SEP Q002 Q006 VM OUT 1 2 CR DVDCB-IN 3 CB 4 GND A VM Q375 STBY 7.5V Y-TO-YUV DVD-YIN DVDCR-IN I-HSYNC I-PROT I-BSC O-DGC X1001 O-OSC O-RELAY O-MUTE I-HP HP HP PROTECT Q365,082 CN004 D GND 9 O-MON0 8 O-SAP 7 I-SAP 6 I-STEREN 5 MAIN 1 4 MAIN 2 3 AFT AGC MUTE O-MONO O-SAP I-SDAT SDA O-SCLN SCL I-SAP I-STEREN O-YM 2 O-AGCMUTE 1 YS2/YM O-OSDBLCK I-AFT Y/C JUNGLE O-R R2IN O-G G2IN O-B B2IN IC301 CONTROL TUNING SYSTEM IC001 VTIM I-VPN O-YUYSW BUFFER CN005 E SET9V 10 I-HLDWN 9 HD 8 GND 7 ABL 6 EW 5 VD+ 4 VD- 3 MONITOR 2 V3 SET9V YUYSW I-HLDWN Q003 HD ABLIN EW VD+ CVBS3IN 1 CVBS2IN PIP-L CN006 F 10 SDAT 9 SCL 8 SET5V 7 SET5V BUFFER 30V 6 30V Q310 SET9V 5 SET9V V1 4 GND 3 Y1 2 C1 (RGB DRIVE) FSC-OUT (CRT DRIVE) CVBS1IN N/S MUTE Q700 Y1 CN701 C1 1 BUFFER N/S MUTE Q349,358 MONOUT IKIN Q359 I-CVIN BUFFER BUFFER Q305 Q302,354 AFCFI BUFFER G CN001 1 POWER-SW 2 IR(SENSOR) 3 MENU-SW 4 KEY-SW 5 STBY +5V 6 V2(VIDEO2) 7 GND 8 BUFFER I-POWER X301 I-RMCN Q350,351 COMB Y I-KEY ROUT GOUT Q352,355 BOUT I-MENU STBY +5V NS IN N/S DRIVE N/S COIL + IC1701 Q303 3 4 BUFFER H-VD IK IK IK 1 2 GND GND 2 R,G,B OUT 3 R R 3 R IN Q387,388 4 B B 4 B IN B OUT Q389 5 G G 5 G IN G OUT 6 GND GND 6 7 N/S N/S 7 8 NS MUTE NS MUTE 8 9 H TRAP H TRAP 9 Q356 XTAL CN705 1 CONVERG O-N/S CN303 Q368 Q004 O-LED Q701 COMB C Q369,370 LED IK BUFFER CRT DRIVE IC702 KR 12 R OUT KB 10 H FV G2 FOCUS HV CN704 CN706 BA5-889-BD H — 35 — PICTURE TUBE KG 11 VD- — 34 — N/S COIL - 1 2 — 36 — 1 G2 6 HEATER 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.comA BOARD IC BLOCK DIAGRAMS 6.2 CIRCUIT BOARD LOCATIONS Part Replaced ( HX Board ) Adjustment ( ) A BOARD: IC401 TDA7057AQ/N2 V DY, T505, CRT, IC501, C507, C520, C505, C509, C515, T504, T503, C551, L510, C546, C537, C547, D517, D518, D519, R560, R561, R562, R563, R565, R566, R567, R525........................A Board HV HOLD-DOWN (R564) I+i IC601, PH601...................A Board VA Board B+ VOLTAGE CONFIRMATION 3 Input 1 + 1 DC Volume Control 1 • All voltages are in Volts D Board A Board K Board 6-3. PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS • Voltage is DC with respect to ground unless otherwise noted. • Readings are taken with a 10MΩ digital multimeter. • Readings are taken with a color-bar signal input. • Voltage variations may be noted due to normal production tolerance. • Circled numbers are waveform references. • * : cannot be measured : B + Line • : B − Line • : Signal path • ----- • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytic and tantalums. Reference Information • All electrolytics are 50V unless otherwise specified. RESISTOR • Indication of resistance, which does not have one for rating electrical power, is as follows: Pitch: 5mm Rating electrical power 1/4W (CHIP: 1/10W) • All resistors are in ohms. KΩ = 1000Ω MΩ = 1000KΩ • : nonflammable resistor • : fusible resistor • : internal component • : panel designation and adjustment for repair • : earth-ground • : earth-chassis • All variable and adjustable resistors have characteristic curve B, unless otherwise noted. in this manual have • The components identified by been carefully factory-selected for each set in order to satisfy regulations regarding X-ray radiation. Should replacement be required, replace only with the value originally used. • When replacing components identified by , make the necessary adjustments indicated. If results do not meet the specified value, change the component identified and repeat the adjustment until the specified value by is achieved (refer to Safety Related Adjustments on page 20). • When replacing parts shown in the table below, be sure to perform the related adjustments. P 4 IC301.............................MA Board CA Board MA Board KV-34FS12T COIL CAPACITOR : : : : : : : : : : : : : : : : : : RN RC FPRD FUSE RW RS RB LF-8L TA PS PP PT MPS MPP ALB ALT ALR Positive Output 1 11 Negative Output 1 10 Positive Output 2 8 Negative Output 2 1 – I–i VREF STABILIZER TEMPERATURE PROTECTION I+i 5 Input 2 7 DC Volume Control 2 METAL FILM SOLID NON FLAMMABLE CARBON NON FLAMMABLE FUSIBLE NON FLAMMABLE WIREWOUND NON FLAMMABLE METAL OXIDE NON FLAMMABLE CEMENT ADJUSTMENT RESISTOR MICRO INDUCTOR TANTALUM STYROL POLYPROPYLENE MYLAR METALIZED POLYESTER METALIZED POLYPROPYLENE BIPOLAR HIGH TEMPERATURE HIGH RIPPLE 13 + 2 – I–i n.c. 2 Signal Ground 6 Power Ground 2 9 Power Ground 1 12 A BOARD: IC502 STV9379 SUPPLY VOLTAGE 2 OUTPUT STAGE SUPPLY 6 FLYBACK GENERATOR 3 Note: The components identified by shading and mark are critical for safety. Replace only with the part number specified. The symbol (displayed on component side of the circuit board) indicates fast operating fuse. Replace only with fuse of the same rating as marked. Les composants identifiés per un tramé et une marque sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Le symbole indique une fusible a action rapide. Doit etre remplacee par une fusible de meme yaleur, comme marque. — 37 — FLYBACK GENERATOR INVERTING 1 INPUT POWER AMPLIFIER NON-INVERTING 7 INPUT 5 THERMAL PROTECTION 4 GND — 38 — OUTPUT 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T [POWER SUPPLY, DEFLECTION, TUNER/IF, AUDIO, MTS] 2 3 R635 R634 R661 R443 CN2008 1 Q507 R423 C613 E R444 9 1 A BOARD LOCATOR LIST CN2007 D206 CN2006 CN2005 R106 R204 CN2002 6 1 SDAT D205 D208 R115 23 21 31 25 15 C630 21 R442 C614 R105 11 9 11 D604 R618 Q101 GND 27 17 13 15 D603 R102 7 L103 3 2 1 SCL 6 L101 AGC R114 CN603 GND 20 R508 6 1 D212 18 6 1 3 1 Q602 KEY STBY-5V V2 GND Y2 B 12 JR002 Q604 R651 CN2001 POWER-SW IR TO MA/MB BOARD MENU C216 11 CN2009 LED-TIMER D213 R235 Q609 B R237 10 DET-OUT 1 R663 9 1 LED-MAIN D2005 11 9 1 C210 8 10 7.5V STBY C631 B A 7 110 R239 6 1-677-295-31 L2 JR2001 CN503 5 1 CN402 R238 4 GND E 1 5V SET Q410 C661 L102 C2 R623 D210 R211 C102 R215 9V SET JR604 JR603 FB602 IC601 CN601 C 4 D606 R632 THP601 FB601 GND R641 R647 L601 IC405 RGO PH601 D611 IC602 C652 R495 IC604 R424 1 C496 R490 C444 CN406 S2007 C547 I D609 R2003 R660 O 4 1 R446 FB603 R627 5 8 C454 R2007 R240 R404 JR409 R439 R436 C448 D202 D203 4 IC406 R566 R643 RY601 5 8 RBK C403 C617 S2008 R206 LBK R644 C615 R2051 D209 IC402 LGO C619 D631 1 FB609 C 1 IC401 Q603 R633 R657 C627 E B 4 CN604 B 5 2 R213 30V CN407 C625 1 R236 J201 C205 C402 R241 Q401 R451 C646 - E + R454 JR503 R450 C608 Q607 C628 R565 R445 D605 C602 R525 18 5 1 TH601 C542 C524 L602 C659 D236 Q205 D510 FB502 R659 D2001 R227 C211 R541 R514 CN408 D400 Q201 R226 C541 GND E C213 R218 R407 H.PROT R527 C527 C607 D234 C546 4 1 D507 R402 D235 R563 R573 R531 C649 10 R225 R403 5 R447 D620 RY602 LGO 8 Q503 R655 1 IC501 R522 Q411 C644 RGO LBK C530 R529 R567 C605 R653 RBK R438 E B 9 Q206 B D 1 E 6 4 C518 2 D232 R231 -13V 7 R506 C525 R540 C543 C511 L509 R532 C519 L502 R561 D616 1 C640 3 S2006 TH501 T601 FB610 L501 D2002 S2004 R507 C624 T604 D514 D517 R537 JR2003 200V L505 H.DRIVE R543 C532 R558 R559 JR501 6 5 H.PULSE F D520 D518 1 1 R601 T504 D233 R511 C629 C633 R232 IC502 1 CN2004 6 R2005 R518 D506 2 C550 R539 CN502 R557 D511 C513 C606 T503 C603 S G Q505 G S2003 R555 C552 CN511 C611 Q605 R554 HEATER D516 6 4 1 R535 C654 R609 V DY - R617 V DY + E S2002 T602 CN506 Q606 D624 B T502 5 R800 Q501 R614 B 4 R505 H S2001 R2020 D627 3 F601 R2015 1 7 CN515 R524 R516 CN602 H DY - C Q502 H-OUT R503 +B AC IN 2 R804 R504 R515 C505 H DY + 1 H DY + CN501 C509 C536 R545 C515 D521 T505 L510 REPLACE FUSE I R802 R803 C503 6.3A C699 R801 H DY - C555 C504 T6.3AL S2005 JUMPER-ID 135V 5 1 R533 R546 FBT AS MARKED RISK OF FIRE C554 R502 AC IN — 39 — VDR601 CN504 L507 R547 R568 C551 R534 R553 — 40 — DIODE D201 C-11 D202 C-11 D203 C-11 D204 B-10 D205 A-11 D206 A-11 D208 A-11 D209 C-11 D210 B-11 D211 C-11 D212 B-1 D213 B-1 D214 D-11 D215 C-11 D230 D-11 D231 D-11 D232 E-11 D233 E-11 D401 D-8 D501 H-8 D502 G-9 D503 G-9 D504 H-8 D505 G-7 D506 F-8 D507 E-8 D508 D-9 D509 H-5 D510 E-10 D511 G-10 D512 E-9 D513 F-10 D514 F-11 D515 E-9 D516 G-11 D517 F-11 D518 F-11 D519 D-10 D520 F-12 D521 I-5 D522 E-9 D601 D-2 D602 E-2 D603 B-3 D604 B-3 D605 D-4 D606 C-3 D607 B-4 D608 B-3 D610 B-4 D611 C-6 D612 D-2 D613 C-6 D614 C-6 D615 F-5 D616 F-6 D617 H-2 D618 H-2 D619 D-2 D620 D-7 D622 F-3 D623 G-2 D624 G-5 D625 H-2 D626 G-1 D627 H-2 D628 G-2 D2001 E-2 D2002 F-1 D2003 B-1 D2004 A-2 D2005 A-2 IC IC401 C-9 IC501 D-9 IC502 F-10 IC601 B-5 IC602 C-7 IC603 D-7 IC604 C-8 IC2001 E-1 TRANSISTOR Q101 A-9 Q410 B-7 Q411 D-8 Q501 H-7 Q502 H-7 Q503 D-9 Q504 E-9 Q505 G-12 Q506 A-6 Q507 A-6 Q601 B-3 Q602 A-3 Q603 C-6 Q604 A-5 Q605 G-3 Q606 H-3 Q607 D-2 Q608 D-2 Q609 A-4 SET 5V 7 SCL 8 SDAT 9 PIP-L 10 TP101 C215 1 16V R115 0 SET 9V D2003 RD9.1EW-T1 2 MAIN2 3 MAIN1 4 6 O-SAP 7 O-MONO 8 GND 9 R602 4.7 :FPRD R608 22M 1/2W D623 ERA22-08TP3 Q605 2SK2663 CONVERTER V Q101 2SD601A AGC C204 0.0047 B:CHIP 30V R237 220 CHIP C216 4.7 D212 MTZJ-T-77-10B R238 220 CHIP C210 4.7 VIDEO L R235 470k CHIP R R617 22 R612 680 D233 RD9.1EW-T1 9V 2SD601A R205 33k :CHIP D626 D1NL20U-TA STBY RECT 5 9 6 8 R611 47k MONIT-L MONIT-R 2 1 VAR/FIX-R VAR/FIX-L C643 0.047 Q606 PROTECT JW664 15MM 2 J203 3P REAR A/V SET+5V 30V C403 0.22 D201 RD9.1EW-T1 D202 RD9.1EW-T1 STBY 7.5V 1 C207 2.2 D209 UDZ-TE-17-9.1B C208 2.2 R214 470k R215 470k :CHIP JW602 12.5MM R635 2.2k CHIP Q609 2SC3311A-QRSTA DGC DRIVER 4 C611 3300p 250V C606 3300p 250V C607 0.47 125V 3 2 R653 1k CHIP C602 47 R601 4.7M 1/2W VDR601 F601 6.3A/125V 2 AC IN 1 Q507 2SB709A SW D608 MTZJ-T-77-20B Q506 2SD601A SW D604 RGP02-17PKG23 CN603 3P OCP/FB 3 FB601 0UH C618 470p B FB609 0UH D611 R633 680 C630 4700p 250V 4 1 3 2 C614 0.1 C613 10 C554 220p C536 470p 500V R640 1k 3 SET+9V 5 R548 4.7 2W CN2003 3P R650 0.68 I G TO HX BOARD CN4001 R658 0.68 1 R520 47 2W LOW B C628 100 25V R522 1k C526 1 FB503 1.1UH D506 RGP10GPKG3 Q503 2SD601A PIN DRIVE 4 — 41 — 7 4 R518 6.8k C542 47 R536 1.8 1/2W D522 1SS133T-77 R517 10k D510 GP08DPKG23 R539 2.2 :FPRD TP507 VP SGND VC2 OUT2+ PGND2 OUT2- OUT1- PGND1 OUT1+ IN1 IN2 TP506 H OUT JW542 15MM SW502 CN901 6 V DY + 5 V DY - 4 H DY - 3 H DY - 2 H DY + 1 H DY + H.DY H.DY V.DY 9 V.DY Q504 pin volt B 0.1 C -6.5 E 0.0 Q505 pin volt B 134.9 C 1.8 E 135.5 Q506 pin volt B 0.0 C 0.0 E GND Q507 pin volt B 0.0 C 0.0 E 0.0 Q601 pin volt B -33.0 C -33.0 E -33.1 Q602 pin volt B -32.8 C -23.6 E -32.9 R563 22k D511 RGP10GPKG23 R544 0.47 C553 22 250V HV 1 FB502 1.1UH Q504 2SC4159-E PIN OUT C540 22 250V C539 22 250V C527 22 R541 10k R511 0.47 R562 12k D519 EL1Z-V1 PROTECT :4G TP502 +13V R537 47 R514 8.2k CHIP 13V TH501 D507 1SS133T-77 :4A R524 10k R525 8.2k D512 MA111-TX D2005 MTZJ-T-77-5.1C D515 MA111-TX R526 22k D508 1SS133T-77 :4A R528 2.2k OUT1 +VCC IN-1 OUT2 IN+1 IN-2 -VCC IN+2 TO CRT FOCUS TO CA BOARD G2 TO CA BOARD CN704 C534 10 R557 470k R554 10k R568 22 2W :RS C551 0.0047 200V C546 22 2 -13V 1 R555 470k D514 RGP15GPKG23 13V REG R550 0.47 1/2W :FPRD 7 FV 13V 8 G2 9 JR522 7.5MM 11 NC 3 GND 4 GND 5 9V 6 HP DF H 0 -13V C531 0.068 200V :PT TO D BOARD CN800 A BOARD WAVEFORMS 1 2 R567 10k :CHIP R565 10k 13V R545 4.7k 1W 3.4 Vp-p (H) JW599 12.5MM JR526 15MM JR527 10MM TP510 HEATER CN504 5 190.5 Vp-p (H) 6 DF L507 2.2mH 27.9 Vp-p (V) 54.3 Vp-p (V) 29.0 Vp-p (V) 9 R566 10k CHIP C699 0.0047 250V C529 0.0022 B:CHIP IC501 NJM2903M-TE2 V HOLD CONTROL :HC TO PWB WHEN REPLACING T505 BE SURE TO CHECK THE VOLTAGE VALUE 201.2 Vp-p (H) R564 SEE PAGES 20 AND 21. (POWER SUPPLY) (DEFLECTION) (TUNER/IF) R529 270k R530 18k CHIP C530 0.001 (AUDIO) (MTS) BA5-889-A TO MA BOARD CN001 — 42 — — 43 — 8 7 CONNECT C547 0.01 F 1.08 KVp-p (H) 25.9 Vp-p (H) TO D BOARD CN802 5 D520 MA111-TX C549 220 16V 4 3 V PULSE JR528 7.5MM 1 R546 0.47 CN515 7P ABL R535 100k R533 22k R532 4.7k +13V 135V 2 7 CN502 6P :S-MICRO 0 Q505 2SA1091O-TPE2 OCP R534 33k E HEATER 1 C533 470 25V R558 100k NC 3 T505 FBT 2 200V 5 200V 200V L510 6 TP504 AT (TP503). REFER TO THE SAFETY ADJUSTMENT SECTION C528 0.0022 B:CHIP Q607 pin volt B 0.7 C 0.1 E GND Q608 pin volt B 0.0 C 0.7 E GND Q609 pin volt B 0.0 C 13.9 E GND All voltages are in V HV 4 +B 6 C537 22 R564 56k CHIP TP503 C524 220p 500V B Q603 pin volt B -23.6 C -31.2 E -23.6 Q604 pin volt B 0.1 C 4.1 E GND Q606 pin volt B -36.1 C -35.3 E -36.3 D503 GP08DPKG23 4 R559 10k -13V 7 C511 0.82 250V D502 GP08DPKG23 R551 22 3W 8 7 5 6 6 SW501 CN2001 8P GND V2 KEY-SW STBY-5V 3 4 MENU-SW IRSENSOR 2 POWER-SW 1 LED-TIMER 3 1 2 HP MUTE RELAY 4 DGC 5 I-PROT 8 7 6 GND 9 CN003 VM TO MA BOARD SPSW CN2008 9P STBY-7.5V 3 2 1 V3 VD- MONITOR 4 VD+ 7 6 5 EW ABL 9 8 HD GND 10 CN005 SET-9V TO MA BOARD I-HLDWN CN2006 10P R513 10 3W 13V C543 0.22 13V D2004 MTZJ-T-77-5.1C 5 C541 220 R538 330 2W TO VA BOARD Q501 pin volt B 0.0 C 93.3 E GND Q502 pin volt B -0.1 C 133.0 E GND Q503 pin volt B 0.2 C 3.8 E GND H.PROT R523 10k C506 0.001 R569 1.8 1/2W 3 +B R512 68 3W L503 10mH L506 10mH R556 1k 7 IC502 STV9379 V OUT C525 100p 500V R521 470 D2002 MTZJ-T-77-10B R519 5.6k 6 2 1 R540 10k L501 8mH C521 2200p 500V O IC603 PQ09RF21 9V REG L505 TP601 R503 4.7k C550 0.47 250V C512 0.068 200V R549 0.47 +B Q501 2SC3209LK H DRIVE L604 C513 0.001 100V B R543 220k :CHIP D513 RGP15GPKG23 -13V REG C523 470 25V -13V FB501 1.1UH 5 CN506 5P CN501 6P WHT :DY R506 33 2W L502 2.2mH D516 1SS133T-77 :4A TP501 8 R501 4.7k T504 HLT R505 47 C504 470p 500V C501 470p R507 1k 1/2W -13V 7 Q604 2SD601A RELAY DRIVE 6 NC 8 V OUT R553 0.33 2W 6 D214 RD9.1EW-T1 D211 RD9.1EW-T1 3 9V 3 TP 508 3 +B 5 4 C535 0.47 2 1 H.DRIVE R510 330 C503 470p 500V Q502 2SD2580-YB H-OUT 4 E 4 1 9V R561 120 DRIVE+ R663 22k 3 2 2 +B D517 1SS133T-77 HOLD DOWN REF :4A 4 R504 JW(7.5MM) 9V 3 Q101 pin volt B 0.0 C 5.6 E GND Q410 pin volt B 0.0 C 5.2 E GND Q411 pin volt B 5.3 C GND E 5.2 TO CA BOARD CN706 1 R642 47k 2 GND C627 0.1 250V 200V 2 1 TP500 C517 0.1 250V 3 STBY 5V D215 RD9.1EW-T1 R661 2.2k 1 D505 RU4AM-T3 VM 2 9V D518 MTZJ-T-77-7.5X TEMP CORR 4 CN302 T501 HDT 2 C502 0.047 200V C505 680p 2kV C508 0.01 100V 1 R639 2.2k 4 R509 680 2W STBY 7.5V TO MA BOARD 9V C514 0.82 250V 3 R2001 2.2k CHIP R502 560 2W 9V C520 0.051 400V 3 R2002 1.5k CHIP R2004 6.8k CHIP C515 680p 2kV 2 CR R2003 4.7k C2001 47 25V CN301 4P KEY-SW C625 1000 25V R659 10 1W IC602 EA135-F12 ERROR AMP D509 MTZJ-T-77-5.6C BOOST CB J206 3P Y,CB,CR 1 5 R2005 0 Y D2001 LNK0120022G R2007 470 2 1 3 +B R560 47k 1W :RS OUT 2 C658 1000 25V D620 D5LC20U AUDIO RECT C631 4700p 250V L601 JW(5mm) AUDIO VCC L504 T503 PMT 1 NC DGC 3 D501 ERC06-15S DRIVE- 1 C507 22000p 1.2kV A BOARD TRANSISTOR VOLTAGE LIST +B 9 C509 680p 2kV R547 560 2W D504 ERC06-15S 8 C555 4700p 1.2kV +B S2008 MENU/SEL 10 CN604 3P DGC FB605 0UH 9V S2007 UP/DOWN Q605 pin volt D -35.6 G 40.8 S 36.8 R445 10k C659 15000 25V C626 15000 25V C622 680p 500V C548 100 160V IC2001 SBX3081-71 IR DETECT Q411 2SB709A VOL CTRL +B FB606 0UH D521 1SS133T-77 R516 4.7k 9V A BOARD TRANSISTOR VOLTAGE LIST L602 JW(5mm) C624 100 160V C623 680p 500V C510 2.2 200V R570 22k + SPL R652 JW(5MM) JW616 5MM C652 0.001 VCC- 3 POWER-SW D1NL20U PH601 PC123FY2 PHOTOCOUPLER REF 2 AUDIO L+OUT R643 1.5k C619 470p :PT VCC+ 1 NC GND 10 +B DGC CR CB 11 JW615 5MM T603 SRT Q603 2SA1309A SW R651 10k 7 D614 C620 100 25V R641 1 2W 12 9 C617 680pF 1.5kV :PP R628 JW(5MM) 8 N/C N/C N/C N/C N/C 4.7 4.4 5.0 5.0 0.3 0.0 0.0 0.0 0.0 4.5 4.5 All voltages are in V D616 D5LC20U LOW B RECT R638 33 R646 1.5k D1NL20U R625 47k R620 1k 13 D1NL20U FB603 0UH FB602 0UH +B Y-TO-YUV D613 R644 3.3k D1S4-TA Q602 2SC3311A SW D615 RU4AM-T3 +B RECT 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 SPK LSPK L+ C654 10 160V FB610 0UH 17 14 R624 10k D607 1SS133T-77 R619 47k C609 100 R660 15k 3W R627 390k C621 1500p 2kV FB604 0UH R649 1k Q601 2SD2144S-TP-UVW SW D603 MTZJ-T-77-33B R572 4.7k :CHIP 1 R632 0.1 2W R622 100k R618 82k DGC R440 100k 2 5.0 3 GND TU101 pin volt 1 8.6 2 30.7 3 5.1 4 4.9 5 4.9 6 GND 7 5.5 8 2.1 9 8.9 10 4.1 11 0.0 All voltages are in V R447 4.7k Q410 2SD601A VOL CTRL GND IC603 pin volt I 13.3 O 8.9 G GND 4 13.3 IC604 pin volt 1 13.3 2 5.0 3 GND IC2001 pin volt 1 5.0 + SPR LOW B R623 470 1/2W 10 R571 4.7k :CHIP LOW B 2 D610 C612 820 250V D606 TF541M 1 2 3 4 R508 22k R613 2.2M 3 C442 4.7 R442 100 3 SPK R- 3 JW414 10MM -13.9 0.2 14.3 2.1 IC601 pin volt 1 -31.8 2 -32.7 3 53.2 4 -23.8 5 -32.7 IC602 pin volt 1 135.9 2 123.4 SPK R+ 2 R446 33k 4 5 6 7 C441 1 16V 15 FB600 0UH R662 R637 JW(20MM) JW(20MM) C647 0.0047 250V R621 6.8 10W C610 C655 0.47 125V 4 4 2 C646 0.0047 250V C644 0.0047 250V T602 LFT CN602 2P D605 D4SB60L-F AC RECT C645 0.0047 250V JW604 12.5MM JW609 7.5MM CN406 4P AUDIO R+OUT IC501 pin volt 1 0.2 2 3.7 3 2.5 4 GND 5 9.5 6 10.1 7 0.1 8 14.0 IC502 pin volt 1 2.1 2 14.0 3 -12.6 16 R626 0.47 1/2W R656 10k Q608 2SD601A SW R630 2.2k RY602 RELAY AC POWER JW606 12.5MM T601 LFT 1 Q607 2SD2144S-TP-UVW STBY DRIVER D612 MTZJ-T-77-10B 5 R655 1k CHIP JW603 12.5MM JW610 7.5MM R634 10k CHIP D210 MTZJ-T-77-10B C601 0.1 25V CHIP D602 1SS133T-77 D601 1SS133T-77 AC IN B+ V MID R636 JW(5MM) S JW614 5MM THP601 IC601 STR-F6626 CONVERTER R607 22 LOW B AUDIO L-OUT R454 100 R441 22k R645 10k GND RY601 RELAY JW613 5MM C648 0.22 125V 18 5 D619 MTZJ-T-77-10B STBY 7.5V D208 MTZJ-T-77-10B R R-OUT D401 MTZJ-T-77-10B L603 V L AUDIO R420 3.9k CHIP AUDIO L TP600 J201 4P S-VIDEO D206 RD9.1EW-T1 R-OUT LOW B VIN 2 AUDIO 4 D 1 R211 75 Y 4 IC401 pin volt 1 0.6 2 0.0 3 2.4 4 14.3 5 2.4 6 GND 7 0.6 8 6.9 9 GND 10 6.9 11 6.9 12 GND 13 6.9 L+OUT 9V L605 3 13 JW252 5MM +B S 12 9V STBY 7.5V C 11 SET 9V AUDIO R D205 RD9.1EW-T1 10 1 R648 33 3W C205 4.7 :CI 9 C402 2200 25V R202 470k R201 470k R208 15k 3W D204 MTZJ-T-77-30D 30V REG :40 8 AUDIO R AUDIO VCC 3 7 PS401 LINK AUDIO VCC 1 C657 47 25V TP602 AUDIO R LOW B 6 R439 4.7k CHIP LOW B IC604 NJM7805FA 5V REG 5 C421 0.22 25V D232 RD9.1EW-T1 R203 75 D203 RD9.1EW-T1 C639 22 4 C420 0.22 25V F R437 4.7k CHIP R438 4.7k R412 470k JR505 0 D628 D1NL20R C604 0.0033 VC1 5 4 3 9V OUT-L OUT-R 6 GND 8 7 V3-L YUV-R YUV-L 9 11 10 V1-L V1-R V3-R 12 13 MUTE 15 14 16 TV-R R436 4.7k FB608 JW(5MM) R614 470 3 FB607 JW(5MM) C636 330 C637 0.001 D627 MTZJ-T-77-7.5A R616 6.8 1/2W AUDIO L D625 1SS133T-77 R610 10k CHIP C638 470p R239 470k CHIP D213 MTZJ-T-77-10B R609 1k 2 AUDIO 3 C635 0.001 1 AUDIO L R411 1k R413 470k R414 1k 1 D624 1SS133T-77 S 5 I-SAP D622 D2SB60A-F04 AC RECT T604 SRT :STAND BY C634 0.01 250V 4 CN004 AFT C641 10 450V J202 3P FRONT A/V J402 2P REAR-VAR/FIX R603 470k :RN TH601 R421 4.7k R422 4.7 C214 1 16V F D231 RD9.1EW-T1 5.0 AUDIO L R204 22k :CHIP 1 MONO 0 AUDIO R 9V TO MA BOARD AGC-MUTE R433 470k AUDIO L R108 100 :CHIP R105 4.7k CN2007 9P STEREO PIN20 R431 1k D230 RD9.1EW-T1 AUDIO R C100 0 A BOARD IC VOLTAGE LIST AUDIO L 6 4.9 IC401 TDA7057AQ/N2 AUDIO AMP JR472 JW(5MM) 5 30V I-STEREN C101 0 VIDEO 4 SET 9V 0 R V1 0.3 V 3 PIN22 R429 470k D618 1SS133T-77 2 0.3 D617 MTZJ-T-77-12C Y1 GND MONO 4.9 R 1 :CHIP L101 C1 9V SAP 0 L :CHIP :CHIP CN006 C105 47 25V L103 C102 100 L102 STEREO PIN21 DET OUT CN450 AUDIO R TO MA BOARD R107 100 :CHIP L TP102 C104 470 25V NC R430 1k C219 10 CN460 20P TO K BOARD N.C. RF-AGC CN2005 10P 18 19 20 R L S OUT R OUT L OUT MUTE SMD SAP LED MODE F MONO DET OUT ST LED DET OUT2 NC AFT OUT NC VCC 9V RF AGC OUT IF OUT ENABLE CLOCK DATA VCC 5V VCC 9V TU101 BTF-WA412 J205 2P YCBCR AUDIO INPUT KV-34FS12T AUDIO L TP100 VCC 30V STEREO 17 V2-R V2-L A Board Schematic Diagram TV-L 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com — 44 — 2.4 Vp-p (V) 9V Q003 2SD601A BUFFER VM SPSW 8 CN2008 MA BOARD TRANSISTOR VOLTAGE LIST 9 GND I-PROT STBY 7.5 V 6 7 DGC 4 3 5 MUTE RELAY HP 1 2 O-SAP GND 9 8 I-SAP 6 5 7 MAIN1 ISTEREN MAIN2 4 TO A BOARD Q001 pin volt B 5.0 C GND E 5.6 Q002 pin volt B 4.4 C 9.0 E 3.8 Q003 pin volt B 0.6 C 0.0 E GND Q004 pin volt B 4.9 C GND E 3.9 R308 75 CHIP R042 8.2k 5V CN003 9P VIDEO AFT CN2007 AGC MUTE CN2006 3 TO A BOARD 1 CN004 9P TO A BOARD 2 SET 9V CN005 10P 10 HD GND I-HLDWN 8 7 9 EW ABL 5 6 VD- VD+ 4 3 V3 MONITOR 1 2 SDAT 9 10 30V SCL 7 8 V1 SET 9V 4 5 6 GND 2 1 CN2005 3 C1 TO A BOARD Y1 CN006 10P SET 5V MA Board Schematic Diagram O-MONO 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T R301 75 :CHIP STBY 7.5V R260 220 9V 9V 9V 9V D001 UDZ-TE-17-5.1B 61 60 58 59 57 R389 1k CHIP VIDEO R377 2.2k CHIP 12 51 50 49 48 47 46 45 44 L302 R378 0 R394 560 CHIP C390 15p CHIP 3 14 15 3.5 Vp-p (H) 16 VIDEO VIDEO 2 1.4 Vp-p (V) C Q349 2SD601A BUFFER R392 5.6k CHIP FL301 LPF R334 100 CHIP R329 100 :CHIP Q359 2SB709A BUFFER 4 Q305 2SB709A-QRS-TX BUFFER :0B C319 1000 16V 3.4 Vp-p (H) 18 17 3.5 Vp-p (H) 19 CN302 4P TO A BOARD AGC MUTE 43 41 42 R357 75 36 37 38 39 40 35 34 9 10 11 12 13 14 18 17 16 15 20 19 21 22 23 63 64 IK 33 62 61 60 59 58 57 56 53 54 55 49 50 51 52 48 47 46 44 45 42 43 25 24 26 28 27 41 40 39 32 31 30 29 38 35 36 37 33 34 D302 JW(5MM) R376 75 1 Y-TO-YUV 2 YCR 3 YCB 4 GND 1.1 Vp-p (H) 1.4 Vp-p (H) CN301 DVD CV AGC MUTE 4.0 Vp-p (H) 3.6 Vp-p (H) DVD CR AGC MUTE 2.9 Vp-p (H) R395 560 CHIP DVD Y VIDEO 11 1.4 Vp-p (V) 13 9V 52 8 7 6 C034 0.022 25V B:CHIP AGC MUTE R351 470 CHIP T-MODE 53 54 5 4 R088 680 :CHIP 8 3.1 Vp-p (H) 10 2.2 Vp-p (H) R324 4.7k :CHIP AGC-MUTE R354 100 CHIP R328 100 CHIP F MONO 55 56 3 5V SAP LED VIDEO C391 100 16V ST LED Q358 2SD601A BUFFER R300 0 6 C318 0.01 CHIP 0.8 Vp-p (H) F MONO 62 2 1 R025 5.6k 63 32 R026 5.6k 64 31 R027 5.6k SSCP YIN YOUT SCL SDA FSC-OUT STBY 7.5V VBSS-IN SGND CVBS4IN TC2 TC1 C341 18p CH:CHIP 1 R086 680 :CHIP 7 4.7 Vp-p (V) 9 9V G R087 680 :CHIP 0.9 Vp-p (H) 6 5 1.0 Vp-p (H) VIDEO R 3.8 Vp-p (8 MHz) 4.7 Vp-p (H) R388 100 CHIP X301 C365 0.47 CHIP B VIDEO MAIN CVBS3=IN NC G ABL-FIL NC XTAL R370 10k C380 0.01 CHIP CVBS2-IN APED ABL-IN VCC2 APC-FIL C362 47 25V C381 0.01 CHIP 4 R387 100 CHIP R274 0 CHIP R L305 CVBS1-IN C1-IN DVDCB-IN DVDCR-IN Y1-IN C2-IN SVCC GND2 DVDY-IN PIPCB-IN Y2-IN MONOUT VT1M PIPY-IN PIPCR-IN C-OUT GND1 VCC1 YUV-SW C361 0.1 B 3 3 C325 0.47 25V F:CH C377 4.7 C363 0.1 25V F C367 470p R356 100 CHIP R004 3.3k :CHIP R055 4.7k :CHIP C359 0.1 B C322 0.47 25V F:CH R360 68k R R061 220 :CHIP R011 220 :CHIP C348 0.47 25V F:CHIP C382 0.01 CHIP C321 0.47 25V F:CH 2 1 C326 0.1 25V B 4 L301 D075 MA111-TX D005 MTZJ-T-77-5.6C Y-CLAMP C037 0.0022 B:CHIP R358 68k C323 0.1 25V B 5 C COMBC-IN G-IN C353 0.01 B R263 100 CHIP R306 100 CHIP 6 C395 0.01 CHIP R283 39k :CHIP VIDEO MA BOARD WAVEFORMS C329 0.1 25V B C320 0.47 25V F:CH C357 47 25V R349 100 CHIP B D003 MA111-TX C324 15p Y R273 10k 8 C356 0.1 25V B C352 0.01 B C339 1 D301 MTZJ-T-77-5.1C 9 R-IN B-IN B YS2/YM 14 C396 0.1 CHIP 7 COMBY-IN HVCC HGND PIP-OUT G-OUT R-OUT 15 G R EW VDP 4.9 I-REF 0 IK-IN MONO R051 220 CHIP 0 16 R347 100 CHIP C330 1 R317 100 Q355 2SB709A BUFFER R368 560 CHIP All voltages are in V C VIDEO C364 0.1 25V B C360 0.47 IC301 CXA2154S Y/C JUNGLE B-OUT 0 4.9 SAP VDN 0 STEREO B C021 220p :CHIP 13 C334 330p B 10 R340 100 CHIP C331 0.01 R280 6.8k G B HD R282 2.2k CHIP AFC-FIL HP/PROTECT PIN56 H-VD REG O-R PIN48 VM-OUT I-HP 12 R269 1k CHIP G R028 1k :CHIP R060 220 C038 470 25V O-B R010 220 :CHIP L002 R071 4.7k :RK-CP O-G O-MONSW R040 220 R044 220 R036 1k CHIP R064 0 R :CHIP STBY 5V C398 10 C077 220p CHIP C011 220p CHIP R326 10k R R327 100 C055 JW(5mm) O-OSDBLK C093 220p :CHIP C071 0.001 CHIP B 11 O-AGCMUTE O-MONO O-ANTSW R091 10k CHIP I-STEREN I-SAP I-BINT IO-MARKER O-YM C012 0.001 B:CHIP C076 220p CHIP G 4 9V R304 100 C315 47 25V C328 0.1 25V B R323 100 C060 470p B:CHIP I-VP I-HSYNC I-PROT I-AFT I-RMCN I-MENU S-DET O-MUTE O-SAP R045 4.7k :CHIP C041 27p :CHIP O-RELAY O-SPSW O-SCLKN O-BCLKN O-STLED R032 220 R046 220 1 C040 12p :CHIP O-NS O-YUVSW I-POWERN O-3DRESET R033 220 R099 47k R047 4.7k :CHIP C097 0.001 CHIP C043 0.001 CHIP I-HLDWN O-DGC C070 0.001 CHIP IO-BDAT R041 680 IO-SDAT GND O-LED 2 VIDEO C091 0.022 B:CHIP 1 I-KEY 3 B-INT IC001 M37280MK-112SP TUNING CONTROL SYSTEM I-AFT2 B-DAT L040 4 XO-OSD FOR JIG I-RESET VCC XI-OSD CN002 4P HLF 2 I-AVCC 1 I-CVIN 2 I-VHOLD GND CLK I-CNVSS 3 I-OSC DAT VSS CN402 O-OSC TO K BOARD C033 220p CHIP C028 220p CHIP C027 0.001 CHIP C042 220p CHIP R322 100 30 C022 560p CHIP R039 680 :CHIP CN309 3P R074 4.7k CHIP Q387 2SB709A BUFFER R021 10k :CHIP R052 1k :CHIP R359 2.2k CHIP Q387 pin volt B 1.9 C GND E 2.5 Q388 pin volt B 1.9 C GND E 2.5 Q389 pin volt B 2.0 C GND E 2.6 C335 4.7 Y R312 1k 29 R017 4.7k C044 0.001 B C048 220p CHIP Q389 2SB709A BUFFER 28 R016 470 :CHIP C016 15p CHIP C019 220p CHIP C017 1 Q388 2SB709A BUFFER 27 VIDEO C032 0.1 25V CHIP R383 0 :CHIP R384 0 :CHIP 26 FB002 0UH R038 1k :CHIP R007 100 3 6 R366 1.5k CHIP Y C358 47 25V 25 X001 :SV C015 15p CHIP R024 220 Q004 2SB709A SW R019 470k CHIP Q350 2SB709A BUFFER 2 FL303 LPF Q368 pin volt B 2.4 C 9.0 E 2.4 Q369 pin volt B 7.6 C 5.8 E 8.3 Q370 pin volt B 5.8 C GND E 6.4 Q375 pin volt B 5.0 C 9.0 E 4.4 9V R262 100 24 R332 75 CHIP C020 0.1 25V F:PT C047 220p CH:CHIP 23 VIDEO R050 220 22 R097 560 21 R013 1k :CHIP C045 0.0022 :CHIP C046 47 25V R337 2.2k :CHIP R382 0 CHIP 20 L003 :CHIP R336 2.2k :CHIP 19 STBY 5V R335 2.2k :CHIP Q375 2SD601A VM OUT R303 10k CHIP 9V 1 Q356 pin volt B 0.5 C 1.3 E GND Q358 pin volt B 2.4 C 8.9 E 1.8 Q359 pin volt B 2.1 C GND E 2.7 Q365 pin volt B 0.5 C 3.8 E GND L310 18 8 R399 39k CHIP C389 0.047 CHIP R398 330k :CHIP 17 7 R346 100k :CHIP 16 V2 D004 UDZ-TE-17-5.1B CHIP R345 100k :CHIP R343 100k :CHIP 15 6 GND B-CLK R022 220 R020 220 :CHIP R333 5.6k CHIP R364 100 CHIP Q351 2SB709A BUFFER R311 100 CHIP 14 5 R073 4.7k D002 MTZJ-T-77-10B R018 220 L308 D305 MTZJ-T-77-5.1C 13 4 KEY-SW R015 10k :CHIP C371 47p CH R313 1k CHIP 12 MENU-SW C099 1 R014 10k :CHIP R342 1k :CHIP 11 3 R276 33k CHIP Q368 2SD601A BUFFER R261 470k :CHIP R365 100 CHIP 9V 10 2 R043 1k R338 10k :CHIP R341 47k :CHIP R277 3.3M :CHIP C336 47 25V R275 22k CHIP R339 56k CHIP Y 9 POWER-SW IRSENSOR) R037 220 C316 47p CHIP Q303 IK BUFFER 2SB709A 8 1 STBY-5V R056 4.7k FB001 0UH 5V CN2001 LED-TIMER C338 0.1 25V B:CHIP 7 TO A BOARD R344 0 :CHIP Y R331 1k CHIP R363 390 CHIP 6 R009 1M :CHIP R362 270 CHIP STBY 5V C009 220p :CHIP Q352 2SD601A BUFFER 9V 5 Q006 2SB709A BUFFER R023 10k C313 0.01 :CHIP 4 R281 4.7k R259 10k :CHIP R258 4.7k Q002 2SD601A BUFFER R008 1k C010 0.047 Q365 2SD601A HP R094 4.7k :CHIP 3 R012 680 :CHIP 9V R310 1k Q082 2SD601A HP 2 STBY 5V 9V Q001 2SB709A BUFFER R003 100 Q351 pin volt B 7.8 C 4.0 E 8.4 Q352 pin volt B 2.5 C 7.8 E 1.9 Q354 pin volt B 2.5 C GND E 3.2 Q355 pin volt B 0.0 C GND E 3.0 1 C006 10 R077 100k :CHIP VIDEO C003 0.47 R002 470 R257 1k :CHIP R256 10k CHIP R093 4.7k CHIP R005 0 VIDEO Q356 2SC2412K-T-146-Q CONVERGENCE R253 1k CHIP R092 4.7k :CHIP R006 100 :CHIP R001 560 C370 100 16V D360 DAP202K R251 4.7k :CHIP STBY 5V CN001 8P R267 1k CHIP R268 680 Q305 pin volt B 4.4 C GND E 5.0 Q310 pin volt B 4.8 C GND E 5.4 Q349 pin volt B 4.4 C 9.0 E 3.8 Q350 pin volt B 4.0 C GND E 4.7 Q006 pin volt B 5.2 C 0.7 E 5.0 Q082 pin volt B 0.6 C 0.5 E GND Q302 pin volt B 2.5 C 7.6 E 1.9 Q303 pin volt B 3.6 C 0.1 E 3.5 1.2 Vp-p (H) R361 75 YUY SW VIDEO VIDEO T-MODE SDA R030 4.7k CHIP R070 4.7k C350 0.47 FB301 R035 220 :CHIP D006 UDZ-TE-17-9.1B STBY 5V VIN VOUT CD GND RESET GND GND OVD 7 GND 6 G 5 B 4 R 3 GND 2 I-K C062 0.47 C051 470 25V C063 0.47 :MPS G R355 1.5k CHIP C308 0.01 CHIP C307 10p CHIP R305 0 17 R 18 19 20 IC001 pin volt 1 0.5 2 4.8 3 NC 4 5.0 5 0.0 6 0.0 7 2.4 8 4.4 9 NC 10 NC 11 0.1 12 NC 13 0.5 14 NC 15 0.1 16 0.1 17 0.0 18 0.1 VIDEO 18 C305 100 16V 9V 19 9V C368 0.01 CHIP C366 0.01 CHIP R367 2.2k CHIP C C R320 100 CHIP 5V R396 100 C314 15p CHIP R321 560 CHIP Y L304 1 2 R318 56k CHIP 3 C FL302 LPF 6 Q354 2SB709A BUFFER C317 0.01 CHIP 4 R319 22k CHIP R316 5.6k CHIP R379 1k CHIP Q302 2SD601A BUFFER Q369 2SB709A BUFFER R372 560 CHIP R369 220 CHIP R373 100 CHIP R374 100 CHIP R375 1.5k CHIP C Q370 2SB709A BUFFER Y Q310 2SB709A BUFFER B YOUT 8 N/S 16 C309 100 16V C332 0.0012 CHIP 1 VDD2 NS-MUTE C064 0.0047 :CHIP R031 3.3 1W C311 180p CHIP 2 DAVRT STBY 7.5V 9 15 R054 4.7k CN705 H-TRAP R386 820 CHIP C397 0.01 CHIP 3 DAVRB 4 14 C369 0.01 CHIP VRT 3 13 L350 BIAS 2 12 VIDEO MA BOARD IC VOLTAGE LIST F MONO Y COUT 1 11 AIN IC002 MM1476AF(TP) STBY 5V REG VSS1 5 4 VRB TO CA BOARD 6 SAP LED SAP LED 17 5 DIG COMB FILTER VDD1 CN303 9P 7 VDD3 8 4 FIL 3 6 C304 0.01 CHIP C303 0.01 CHIP C302 0.01 CHIP TC90A49P CKIN 2 TEST 1 IC302 7 C340 100 16V VSS2 IC003 M24C16-MN6T MEMORY C039 10 :CI KILLER 5 9 SDA 6 10 VDD4 7 8 C354 100 16V L351 C351 0.01 CHIP C355 0.01 CHIP R353 100 SCL 8 R352 100 ST LED F MONO 0UH L303 5V R034 220 :CHIP SET LED R095 4.7k :CHIP R CHIP SAP LED B 5V 4.7k SCL I-STEREN G R029 SDA SCL R057 100k :CHIP IK R058 100k :CHIP VIDEO T MODE 9V 9V G 1 9V R B 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 4.3 0.1 NC 5.0 NC 5.0 2.1 NC 0.3 2.2 GND 2.2 2.3 GND 5.0 2.5 2.5 5.0 NC 5.0 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 NC NC NC 4.8 4.8 NC 4.8 NC 4.8 0.1 0.1 5.0 5.0 NC 1.0 0.1 NC 1.0 NC 0.1 59 NC 60 NC 61 0.1 62 0.1 63 0.1 64 0.1 IC002 pin volt 1 GND 2 5.0 3 4.9 4 7.2 5 5.0 6 GND 7 GND 8 NC IC003 pin volt 1 GND 2 GND 3 4 5 6 7 8 GND GND 4.8 4.8 GND 5.0 IC301 pin volt 1 NC 2 GND 3 5.2 4 5.0 5 4.8 6 5.0 7 4.8 8 3.4 9 4.8 10 1.7 11 0.0 12 4.8 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 8.9 NC NC 4.8 4.4 GND NC 6.4 3.9 5.6 8.9 NC GND 3.5 2.4 3.5 3.5 5.9 5.5 7.6 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 (TUNING CONTROL) (Y/C/J) BA5-889-MA Board Board — 45 — — 46 — — 47 — — 48 — 3.6 2.3 2.3 3.9 1.9 1.9 2.0 0.0 4.6 4.6 4.6 8.9 0.2 4.3 5.2 5.2 GND 4.8 5.2 5.2 53 9.0 54 5.3 55 1.6 56 1.7 57 1.1 58 7.2 59 4.8 60 4.8 61 4.8 62 NC 63 NC 64 NC IC302 1 5.0 2 1.4 3 3.2 4 2.4 5 1.9 6 5.0 7 0.0 8 9 10 11 12 13 14 15 16 17 18 19 20 5.0 4.9 4.9 0.0 0.0 2.5 2.1 5.0 GND 2.5 3.2 1.9 2.4 All voltages are in V 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T 1 2 3 4 6 5 8 7 A B C D MA BOARD LOCATOR LIST DIODE Q370 A-3 D001 D-2 Q375 B-5 D002 D-4 Q387 C-5 D003 C-3 Q082 B-3 D004 D-3 Q302 A-3 D005 C-1 Q303 C-5 D006 C-2 Q305 B-4 D075 C-3 Q310 B-3 D301 C-7 Q349 C-4 D302 C-5 Q350 B-3 D305 B-5 Q351 B-3 D360 B-4 Q352 B-3 IC Q354 A-3 IC001 C-2 Q355 B-2 IC002 C-1 Q356 D-3 IC003 C-2 Q358 B-4 IC301 D-7 Q359 B-4 IC302 B-1 Q365 C-4 TRANSISTOR Q368 C-6 Q001 D-8 Q388 B-5 Q002 D-5 Q389 C-5 CRYSTAL Q003 D-5 Q004 D-2 X001 D-1 Q006 D-3 X301 C-8 Q369 B-3 HX Board Schematic Diagram KEY CN4001 3P WHT-L :S-MICRO TO A BOARD R4001 100 :CHIP CN2003 1 2 3 R4005 6.8k S4006 R4004 2.2k S4005 S4004 S4003 TV/V CH+ CH- S4002 VOL+ 1 2 3 S4001 VOL- BA5-889-HX — 49 — GND KEY-SW R4002 680 R4003 820 POWER [KEY] POWER-SW A — 50 — 4 5 MA BOARD IC BLOCK DIAGRAM MA BOARD: IC301 CXA2154S [TUNING CONTROL, Y/C/J] 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T CA Board Schematic Diagram [RGB DRIVE, CRT DRIVE] R718 2.2 2W CN704 KG KB G2 TO A BOARD R716 100k 1/2W (T505) G2 1 CRT 1 2 3 H [AUDIO PROCESSOR] FOCUS J701 G2 3 C707 0.0047 2kV E 5 6 CV 1 RV701 VSTAT CONTROL 110M 8 13 G1-3 9 12 10 11 KR CV G1-1 7 R 3 B 4 G 5 GND 6 MUTE C457 1 TP47R R OUT TP47B B OUT N.C. G OUT 8 9 R712 1k 1/2W C430 R713 1k 1/2W -13V 2 +13V 1 C413 1 C405 R469 C404 C JR420 R710 100 R410 D701 1SS83TD R403 1 C C201 0.3V R703 100 1 -0.6V 2 3 4 R479 CN450 CA BOARD WAVEFORMS C703 47 25V Q700 2SC3311A NS MUTE N/S COIL R719 220 2W R704 2.2k 1 R705 10k C702 0.1 :MPS (RGB DRIVE) (CRT DRIVE) R707 1.5 :FPRD -13V 2 3 COIL- 2 NC 3 COIL+ CN701 3P R706 1 1 132.8V p-p (H) 135.9V p-p (H) C701 47 25V BA5-889-CA Boards — 51 — — 52 — R437 Q433 R436 1 D 13V 0.3V R434 C440 5 1.7V R435 R438 R439 IC701 LA6500-FA N/S AMP R702 220 C422 R443 JR429 C708 0.1 :MPS C423 C418 R409 R404 E 20 C419 C409 C450 20 13V Q701 2SC3311A NS MUTE 0.0V C408 C451 D C710 10 0.3V R721 2.2k C410 Q432 -13V 0.0V 21 C490 D703 1SS83TD C709 220 16V R701 10k IC404 AUDIO PROCESSOR C406 R709 100 D702 1SS83TD C704 4.7 250V R720 2.2k Boards & C428 40 6 3 C431 B R711 1k 1/2W 134.5V 144.4V R708 100 R700 22k 200V 4 C446 JR427 12 C411 9 GND R456 IC403 1 S.R.S C432 R 8 HEATER R459 JR426 24 B E R714 100 1/2W 200V 5 13 C415 7 B CN702 :PIN-J D704 RGP10GPK23 C456 A TO A BOARD CN502 200V C426 C412 R OUT 6 CN402 171846413 C424 JR407 R715 560k 1/2W 7 CN706 6P C455 3 B OUT VDD 2.2V IK 5 138.5V C705 10 250V L701 2 H-TRAP 4 3.6V G CN303 N/S 3 2.2V CN705 9P N/S 2 GND 2.0V 1 R IN B IN G IN IC702 TDA6108JF/N1B CRT DRIVE 2 3 1-678-026-13 G1-2 B 1 1 2 1 H2 G IK A KB R GND G4 HV KG 200V TO MA BOARD KR G1 H1 3 G4 (T505) 1 TO A BOARD 140.6V p-p (H) R432 R431 Q430 Q431 R433 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com K Board Schematic Diagram KV-34FS12T VA Board Schematic Diagram SDA GND 1 2 R456 22k R455 22k C418 0.1 :CHIP C417 4.7 C416 4.7 D806 1SS133T-77 C419 1 :CHIP 3 SCL CN402 3P TO MB BOARD CN309 C409 0.0015 B:CHIP C410 0.033 :CHIP C408 0.22 :CHIP 9V R468 0 C411 0.0033 B:CHIP C490 0 R403 0 R404 100 TO A BOARD JW405 5MM CN506 AUDIO-R 6 5 4 3 2 1 IN2A IN1A A BBEA A R408 100 IC404 NJW1130G-TE2 AUDIO PROCESSOR 38 39 IN1 37 IN2 36 IN3 35 IN4 34 IN5 33 IN6 B BBEB B BBEB TONE TONE 32 BBEA TONE 31 7 IN3A 8 TONE B 30 9 IN4A 10 MONB 29 11 MONA P S OUT B 28 LINE 27 A 26 OUT A 25 12 LINE VREF 24 13 AGC AUX0 DAC DAC 23 14 IN5A 15 AGC SDA 22 16 DAC VCC AUX1 21 C446 100 16V 17 DAC GND R443 220k 18 SCL C451 4.7 19 IN6A 20 C413 4.7 R434 4.7k Q432 2SB709A BUFFER Q433 2SB709A BUFFER R438 220 R437 220 C405 0.033 :CHIP C909 0.0047 500V E R410 100 C422 4.7 AUDIO-R C202 4.7 R407 100 :CHIP R918 100 R914 270 C458 JW(5mm) AUDIO-L Q904 2SC3311 AMP 5.4V C907 33 160V C908 470 10V R909 47 1/2W :FPRD R907 2.7 :FPRD Q902 2SA1837 VM.DRIVE.1 135.4V 134.9V R908 560 :FPRD C905 0.047 200V :PT 67.9V D902 MTZJ-T-77-39 R906 18k C901 2.2 160V (VELOCITY MODULATION) R477 220k C906 0.001 :PT C201 4.7 AUDIO-R QP DRIVE S D804 RGP10GPKG23 C805 0.01 630V QP R905 1k :FPRD Q901 2SC4793 VM.DRIVE.2 67.9V R910 180 3W :RS R902 2.7 :FPRD 0.4V D901 MTZJ-T-77-39 0.9V C903 470 10V 1 Q.P.- 2 Q.P.- 3 Q.P.+ 4 Q.P.+ 5 E 6 E 7 VM 8 VM R901 47 :FPRD R903 560 :FPRD R904 18k C904 0.001 :PT 9V R444 220k C902 0.047 :PT BA5-889-VA AUDIO-L L410 C475 0.1 [VELOCITY MODULATION] R478 220k R446 220k C440 0.1 25V F C441 100 1 2 3 4 20 17 18 19 14 15 16 12 13 9 10 11 6 7 8 4 5 1 2 3 (AUDIO PROCESSOR) CN460 V2-L TV-L V2-R TV-R V1-R N.C. MUTE V1-L V3-R V3-L YUV-L YUV-R 9V GND OUT-R OUT-L VAR/FIX-L MON-L MON-R TO A BOARD VAR/FIX-R BA5-889-K CN450 20P A K BOARD IC VOLTAGE LIST 7 8 9 10 11 12 13 14 4.7 4.5 4.5 4.5 NC 4.5 4.5 1.0 15 16 17 18 19 20 21 22 4.5 0.9 0.9 4.8 4.9 GND 8.9 NC 23 24 25 26 27 28 29 30 NC 1.3 1.3 4.4 3.9 4.5 4.5 NC 31 32 33 34 35 36 37 38 4.5 4.5 4.5 4.5 NC 4.5 4.5 4.5 39 40 4.5 4.5 All voltages are in V B C K BOARD TRANSISTOR VOLTAGE LIST Q430 pin volt B 0.3 C 0.0 E GND Q431 pin volt B 0.3 C 0.0 E GND Q432 pin volt B 4.5 C GND E 5.1 Q433 pin volt B 4.5 C GND E 5.2 All voltages are in V — 53 — QP VM CN902 8P JR407 0 Q431 2SD601A MUTE IC404 pin volt 1 4.5 2 4.5 3 4.5 4 4.5 5 4.5 6 NC 9V DRIVE 1 R818 100 1.8V C910 0.1 200V :PT V MOD 2 6.8V C911 100 10V R912 220 V MOD 3 Q905 2SA1309A-QRSTA VM OUT 2.4V R911 68 CN801 4 5.7V 1.8V R913 68 L801 10mH 5.7V 5.4V Q903 2SC3311 AMP R922 22 :FPRD TO D BOARD R826 2.2k AUDIO-R R445 220k R433 0 R921 10k R919 100 R915 1k D807 ERA82-004TP5 6.4V Q906 2SC3311 VM OUT 6.1V R920 820 D903 1SS133 TEMP-CORR R442 220 JR408 0 C450 4.7 R431 10k 1 +B C448 2.2 R432 10k 2 C447 2.2 C423 4.7 Q430 2SD601A MUTE 3 2.4V R405 100 C412 0.1 :CHIP E NC +B C913 0.001 C811 0.082 200V 0.6V Q807 IRF614 QP-H-OUT 9V C912 470 25V R916 1k R469 0 C406 0.0015 B:CHIP 4 AUDIO-R C407 0.22 :CHIP 5 9V L901 AUDIO-L C414 4.7 R435 220 R436 4.7k AUDIO-L C415 4.7 9V VM OUT R917 1k C404 0.0033 B:CHIP JR474 0 C914 0.047 :PT R923 47 R409 100 40 L802 10mH Q808 2SB734 9V DRIVE CN901 5P R470 100 R876 1k CN904 4P D805 1SS133T-77 6.8V — 54 — 5 VM V MOD V MOD CN801 4P D BOARD TRANSISTOR VOLTAGE LIST TO VA BOARD Q801 pin volt B -2.2 C 3.4 E GND Q802 pin volt B 4.3 C GND E 4.9 Q803 pin volt B 6.4 C 4.3 E 7.0 Q804 pin volt B 7.4 C 6.4 E 7.9 Q805 pin volt B 6.7 C 0.6 E 7.3 CN904 4 3 QP DRIVE 1 2 D Board Schematic Diagram 9V DRIVE 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T +B +B 9V 9V +9V R815 68 1W R875 270 :CHIP C825 0.01 :PT R869 100k :CHIP R870 2.2k :CHIP CN800 7P R867 10k :CHIP R868 10k :CHIP C826 100p :CHIP D813 1SS133 PROTECT TO A BOARD CN515 135V 1 NC 2 GND 3 GND 4 9V 5 H.P 6 VD+ Q812 2SA1309A HP 4 R866 10k :CHIP R872 1M :CHIP R864 220 :CHIP R865 100k :CHIP 3 2 R874 330 :CHIP D814 1SS133T-77 R871 680k :RN C823 0.0027 :PP IC803 NJM2903D HP Q811 2SA1309A QP DRIVE 7 5 6 7 +B CN802 1P R852 6.8k 3W R853 JW(5MM) :RS TO A BOARD 4 CN504 3 (FOR DF) DF 6 1 R849 8.2k 3W T801 DF TRANSFORMER C817 0.0027 630V L803 10mH :LHL10 D812 ERB44-06 CLAMP R847 100k C815 0.022 630V :PP R846 100k D811 ERA38-06 DAMP R848 2.2k 2W C816 220p 500V :B 5 R838 100 :CHIP 2 R841 10k CHIP 1 6 7 12k R834 4.7k :CHIP R837 :RN-CP C812 0.01 :CHIP R832 3.3k :CHIP R835 2.2k :CHIP R831 1k :CHIP R828 33k :CHIP 6 7 8 R829 470k R808 10k :CHIP Q804 2SB709A SW R806 22k :CHIP C810 0.1 C801 1 Q803 2SB709A BUFFER D801 MTZJ-5.6C CLAMP Q801 2SD601A BUFFER R809 22k :CHIP R804 10k :CHIP C802 10 R805 4.7k :CHIP R803 22k :CHIP R802 10k :CHIP Q802 2SB709A BUFFER All voltages are in V R801 47k :CHIP BA5-889-D C814 0.01 B:CHIP Q809 2SD601A BUFFER R830 0 :CHIP [CONVERGENCE] 1 2 3 A B D BOARD IC VOLTAGE LIST GND 4.5 4.5 4.5 9.0 IC802 pin volt 1 6.8 2 5.7 3 0.0 4 5 6 7 8 GND 6.8 6.7 3.2 9.0 IC803 pin volt 1 2.3 2 4.3 3 4.7 4 5 6 7 8 GND 7.6 6.7 6.0 9.0 All voltages are in V Boards & C803 0.22 :PP R836 2.2k :CHIP (CONVERGENCE) 4 5 6 7 8 D808 1SS133 C804 0.22 :PP D802 1SS133 R844 JW(12.5MM) D809 MTZJ-15B IC801 pin volt 1 7.3 2 4.4 3 4.5 1 C809 0.33 16V :CHIP 8 R890 100k :CHIP R833 39k :CHIP D810 ERA38-06 CLAMP Q810 2SC3840K SW R845 100k 3 IC802 NJM2903D DF-COMP R850 8.2k 3W R827 4.7k :CHIP R842 3.9k 4 C818 680p 500V 2 1 R839 100 :CHIP C820 0.47 160V 2 R807 3.3k :CHIP 5 R855 56k CHIP R857 33k :CHIP 3 IC801 NJM2904D V-MOD C808 0.01 :CHIP R811 100 :CHIP R816 100 :CHIP R812 3.3k :CHIP R823 4.7k :CHIP 4 R825 100k R854 5.6k CHIP R851 6.8k 2W R817 47k :CHIP 9V 8 Q805 2SB734-T-34 V-MOD Q806 2SD601A V-MOD R822 4.7k :CHIP C807 0.01 B:CHIP R824 100k R860 10k :RN-CP C821 0.01 :CHIP C862 10 R821 3.3k CHIP R862 2.2k :CHIP R814 68 1W R813 470 :CHIP R820 33k :CHIP C824 0.047 :CHIP R863 2.2k :CHIP 1 R819 47k :CHIP R873 10k :CHIP C Board — 55 — Q806 pin volt B 7.3 C 8.1 E 6.7 Q809 pin volt B 0.3 C 0.3 E GND Q810 pin volt B 0.3 C 1.2 E GND Q811 pin volt B 6.3 C GND E 6.4 Q812 pin volt B 0.0 C GND E 0.6 — 56 — 4 5 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T 6-4. SEMICONDUCTORS http://bbs.520101.com 2SB709A-QRS-TX 2SD601A-QRS-TX 2SB734-T-34 2SC3209LK-TP 2SA1309A-QRSTA 2SC3311A-QRSTA 2SD2144S-TP-UVW 2SC3840K LETTER SIDE 2SA1837 2SC4159-E 2SA1091O-TPE2 IRF614 ERA38-06TP1 ERA82-004TP5 1SS133T-77 D1N2OR-TA D1NS4-TA MTZJ-T-7712C MTZJ-T-77-33B MTZJ-T-77-39 ERC06-15S MTZJ-T-77-5.1C MTZJ-T-775.6C MTZJ-T-77-7.5A MTZJ-T-77-10B MTZJ-T-7730D RGP10-GPKG3 RGP02-17PKG23 ERB44-06TP1 1SS83TD D1NL2OU-TA EL1Z-V1 ERA22-08TP3 GP08DPKG23 RGP10GPKG23 RU4AM-T3 RD9.1EW-T1 MA111-TX D2SB60A-F04 DAP202K-T-146 D4SB60L-F — 57 — D5LC20U 更多难得资料请到江南家电维修论坛免费下载！ SECTION 7 http://bbs.520101.com EXPLODED VIEW KV-34FS12T • Items with no part number and no description are not stocked because they are seldom required for routine service. • The component parts of an assembly are indicated by the reference numbers in the remarks column. Note: • Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Note: Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. The components identified by shading and mark are critical for safety. Replace only with part number specified. 7-1. CHASSIS 34 7-685-648-79 SCREW +BVTP 3X12 7-685-648-79 SCREW +BVTP 4X16 4-046-765-12 SCREW, TAPPING 7 4-388-477-01 SCREW 3X16, TAPPING 28 29 20 32 30 27 31 17 19 26 21 25 15 7 33 16 8 12 22 18 23 24 13 6 11 10 14 5 9 2 4 3 REF. NO. PART NO. DESCRIPTION 1 2 3 4 5 X-4037-664-1 3-704-179-31 4-075-658-01 4-047-464-01 4-075-657-01 BEZNET ASSY EMBLEM (NO.9), SONY DOOR CATCHER, PUSH GUIDE, LED 1 REMARK 6 7 8 9 10 4-068-982-02 * A-1372-817-A 1-529-498-11 1-452-896-11 8-735-066-05 MULTI-BUTTON (TOP) HX MOUNTED PC BOARD SPEAKER (13.1X6.2CM) COIL, NA ROTATION (RT200) CRT 34RSN(SDP) 11 12 13 14 15 8-451-499-21 8-453-007-41 * A-1332-061-A * A-1342-549-A 4-053-005-01 DY Y34RSA-X NA324-M4 CA (VAR) MOUNTED PC BOARD VA (VAR) MOUNTED PC BOARD SPACER, DY 16 17 18 1-452-032-00 MAGNET,DISC 4-065-895-04 HOLDER, DGC 4-036-329-01 SPRING (B), TENSION 2-5 REF. NO. PART NO. DESCRIPTION REMARK 19 20 21 22 1-416-827-21 COIL, DEGAUSSING 4-062-047-02 PIECE A(110), CONV CORRECT * A-1343-874-A D (VAR) MOUNTED PC BOARD * A-1299-266-A A COMPLETE PC BOARD The high-voltage leads associated with the FBT on this board are not included and must be ordered separately. (See 29-31) 23 24 25 26 27 8-598-542-00 * A-1304-203-A 1-766-374-11 1-792-874-11 * A-1380-632-A 28 29 30 31 32 33 34 1-453-338-11 1-251-374-13 1-900-800-82 1-900-803-50 3-704-372-71 4-075-654-01 1-500-586-11 — 58 — TUNER, FSS BTF-WA412 MA (VAR) MOUNTED PC BOARD PLUG, F-PIN CORD, AC POWER(WITH CONNECTOR) K (VAR) MOUNTED PC BOARD FBT ASSY NX-4600//X4J4 (29-31) HV CAP ASSY FOCUS LEAD G2 LEAD HOLDER, HV CABLE COVER, REAR FILTER, CLAMP (FERRITE CORE) 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com SECTION 8 ELECTRICAL PARTS LIST Note: The components identified by in this manual have been carefully factory-selected for each set in order to satisfy regulations regarding X-ray radiation. Should replacement be required, replace only with the value originally used. The components identified by shading are critical for safety. Replace and mark only with part number specified. Note: Les composants identifies per un trame et une sont critiques pour la securite. Ne marque les remplacer que par une piece portant le numero specifie. REF. NO. PART NO. * A-1299-266-A • Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • All variable and adjustable resistors have characteristic curve B, unless otherwise noted. DESCRIPTION REMARK A COMPLETE PC BOARD The high voltage leads associated with the FBT on this board are not included and must be ordered separately. Order the following leads when requesting this A Board: 1-251-374-13 HV CAP ASSY 1-900-800-82 FOCUS LEAD 1-900-803-50 G2 LEAD 1-533-223-11 HOLDER, FUSE * 4-374-846-11 COVER, CAPACITOR, CAP TYPE 4-382-854-11 SCREW (M3X10), P, SW (+) CAPACITOR C100 C101 C102 C104 C105 1-216-295-91 1-216-295-91 1-126-933-11 1-126-941-11 1-104-664-11 SHORT SHORT ELECT ELECT ELECT 100µF 470µF 47µF 20% 20% 20% 16V 25V 25V C204 C205 C207 C208 C210 1-163-017-00 1-126-963-11 1-126-961-11 1-126-961-11 1-126-963-11 CERAMIC CHIP ELECT ELECT ELECT ELECT 0.0047µF 4.7µF 2.2µF 2.2µF 4.7µF 10% 20% 20% 20% 20% 50V 50V 50V 50V 50V C214 C215 C216 C219 C402 1-164-346-11 1-164-346-11 1-126-963-11 1-126-964-11 1-126-943-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT 1µF 1µF 4.7µF 10µF 2200µF 20% 20% 20% 16V 16V 50V 50V 25V C403 C420 C421 C441 C442 C501 C502 1-126-957-11 1-164-222-11 1-164-222-11 1-164-346-11 1-126-963-11 1-102-114-00 1-106-383-00 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC MYLAR 0.22µF 0.22µF 0.22µF 1µF 4.7µF 470PF 0.047µF 20% 20% 10% 10% 50V 25V 25V 16V 50V 50V 200V RESISTORS • All resistors are in ohms • F : nonflammable When indicating parts by reference number, please include the board name. REF. NO. PART NO. DESCRIPTION C503 C504 C505 C506 C507 1-102-228-00 1-102-228-00 1-162-116-00 1-162-318-11 1-117-652-11 CERAMIC CERAMIC CERAMIC CERAMIC FILM 470PF 470PF 680PF 0.001µF 22000PF 10% 10% 10% 10% 3% 500V 500V 2KV 500V 1.2KV C508 C509 C510 C511 C512 1-137-150-11 1-162-116-00 1-107-649-11 1-115-521-11 1-106-387-00 MYLAR CERAMIC ELECT FILM MYLAR 0.01µF 680PF 2.2µF 0.82µF 0.068µF 10% 10% 20% 5% 10% 100V 2KV 250V 250V 200V C513 C514 C515 C517 C520 1-104-987-11 1-115-521-11 1-162-116-00 1-107-846-11 1-130-118-91 MYLAR FILM CERAMIC FILM FILM 0.001µF 0.82µF 680PF 0.1µF 0.051µF 10% 5% 10% 5% 5% 100V 250V 2KV 250V 400V C521 C523 C524 C525 C526 1-164-646-11 1-126-941-11 1-102-244-00 1-107-612-11 1-126-960-11 CERAMIC ELECT CERAMIC CERAMIC ELECT 2200PF 470µF 220PF 100PF 1µF 10% 20% 10% 5% 20% 500V 25V 500V 500V 50V C527 C528 C529 C530 C531 1-126-965-11 1-164-161-11 1-164-161-11 1-163-009-11 1-106-387-00 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR 22µF 20% 0.0022µF 10% 0.0022µF 10% 0.001µF 10% 0.068µF 10% 50V 50V 50V 50V 200V C533 C534 C535 C536 C537 1-126-941-11 1-126-964-11 1-126-959-11 1-102-228-00 1-126-965-11 ELECT ELECT ELECT CERAMIC ELECT 470µF 10µF 0.47µF 470PF 22µF 20% 20% 20% 10% 20% 25V 50V 50V 500V 50V C539 C540 C541 C542 C543 1-107-662-11 1-107-645-11 1-126-969-11 1-126-967-11 1-136-169-00 ELECT ELECT ELECT ELECT MYLAR 22µF 22µF 220µF 47µF 0.22µF 20% 20% 20% 20% 5% 250V 160V 50V 50V 50V C546 C547 C548 C549 1-126-965-11 1-163-031-11 1-107-995-11 1-126-934-11 ELECT CERAMIC CHIP ELECT ELECT 22µF 0.01µF 100µF 220µF 20% 50V 50V 160V 16V — 59 — REMARK 20% 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REMARK Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REF.NO. PART NO. DESCRIPTION REF.NO. PART NO. C550 C551 C553 C554 C555 1-117-667-11 1-137-417-11 1-107-662-11 1-102-110-00 1-117-635-11 FILM MYLAR ELECT CERAMIC FILM 0.47µF 5% 0.0047µF 10% 22µF 20% 220PF 10% 4700PF 3% 250V 200V 250V 50V 1.2KV C699 C2001 1-117-703-11 CERAMIC 1-104-664-11 ELECT C601 C602 C604 C606 C607 1-164-004-11 1-126-967-11 1-164-182-11 1-113-923-11 1-136-311-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC MYLAR 0.1µF 47µF 0.0033µF 3300PF 0.47µF 10% 20% 10% 20% 20% 25V 50V 50V 250V 125V CN301 CN406 CN460 CN501 CN502 * 1-564-507-11 PLUG, CONNECTOR 4P * 1-564-507-11 PLUG, CONNECTOR 4P 1-573-298-21 CONNECTOR, BOARD TO BOARD 20P * 1-580-798-11 CONNECTOR PIN (DY) 6P * 1-564-509-11 PLUG, CONNECTOR 6P C609 C610 C611 C612 C613 1-126-968-11 1-126-964-11 1-113-923-11 1-113-611-11 1-126-964-11 ELECT ELECT CERAMIC ELECT(BLOCK) ELECT 100µF 10µF 3300PF 820µF 10µF 20% 20% 20% 20% 20% 50V 50V 250V 250V 50V CN504 CN506 CN515 CN602 CN603 * * * * * 1-508-784-21 1-564-508-11 1-564-510-11 1-580-843-11 1-573-963-11 PIN, CONNECTOR (5MM PITCH) 1P PLUG, CONNECTOR 5P PLUG, CONNECTOR 7P PIN, CONNECTOR (POWER) PIN, CONNECTOR (PC BOARD) 3P C614 C617 C618 C619 C620 1-130-495-00 1-125-893-11 1-164-081-11 1-136-356-11 1-104-665-11 MYLAR FILM CERAMIC MYLAR ELECT 0.1µF 680PF 470PF 470PF 100µF 5% 3% 10% 5% 20% 50V 1.5KV 50V 50V 25V C621 C622 C623 C624 C625 1-125-772-91 1-164-625-11 1-164-625-11 1-131-867-51 1-135-412-51 CERAMIC CERAMIC CERAMIC ELECT ELECT 1500PF 680PF 680PF 100µF 1000µF 10% 10% 10% 1-573-963-11 1-564-511-11 1-564-506-11 1-764-333-11 1-764-333-11 1-564-512-11 1-564-512-11 PIN, CONNECTOR (PC BOARD) 3P PLUG, CONNECTOR 8P PLUG, CONNECTOR 3P PLUG, CONNECTOR 10P PLUG, CONNECTOR 10P PLUG, CONNECTOR 9P PLUG, CONNECTOR 9P 20% 2KV 500V 500V 160V 25V CN604 * CN2001* CN2003* CN2005* CN2006* CN2007* CN2008* C626 C627 C628 C630 C631 1-135-573-51 1-136-189-00 1-104-665-11 1-113-924-11 1-113-924-11 ELECT MYLAR ELECT CERAMIC CERAMIC 15000µF 0.1µF 100µF 4700PF 4700PF 20% 10% 20% 20% 20% 25V 250V 25V 250V 250V C634 C635 C636 C637 C638 1-137-605-11 1-163-009-11 1-126-970-11 1-163-009-11 1-163-005-11 MYLAR CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 0.01µF 0.001µF 330UF 0.001µF 470PF 10% 10% 20% 10% 10% 250V 50V 50V 50V 50V C639 C641 C643 C644 C645 1-126-965-11 1-107-679-91 1-104-760-11 1-161-964-91 1-161-964-91 ELECT ELECT CERAMIC CHIP CERAMIC CERAMIC 22µF 20% 10µF 20% 0.047µF 10% 0.0047µF 0.0047µF 50V 450V 50V 250V 250V C646 C647 C648 C652 C654 1-161-964-91 1-161-964-91 1-136-346-21 1-130-471-00 1-107-636-11 CERAMIC CERAMIC MYLAR MYLAR ELECT 0.0047µF 0.0047µF 0.22µF 20% 0.001µF 5% 10µF 20% 250V 250V 125V 50V 160V C655 C657 C658 C659 1-136-311-11 1-104-664-11 1-135-412-51 1-135-573-51 MYLAR ELECT ELECT ELECT 0.47µF 47µF 1000µF 15000µF 125V 25V 25V 25V 20% 20% 20% 20% DESCRIPTION REMARK 0.0047µF 47µF 20% 20% CONNECTOR DIODE D201 D202 D203 D204 D205 8-719-108-12 8-719-108-12 8-719-108-12 8-719-982-22 8-719-108-12 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE MTZJ-T-77-30D DIODE RD9.1EW-T1 D206 D208 D209 D210 D211 8-719-108-12 8-719-108-12 8-719-977-22 8-719-110-17 8-719-108-12 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE UDZ-TE-17-9.1B DIODE MTZJ-T-77-10B DIODE RD9.1EW-T1 D212 D213 D214 D215 D230 8-719-110-17 8-719-110-17 8-719-108-12 8-719-108-12 8-719-108-12 DIODE MTZJ-T-77-10B DIODE MTZJ-T-77-10B DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 D231 D232 D233 D401 D501 8-719-108-12 8-719-108-12 8-719-108-12 8-719-110-17 8-719-945-80 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE RD9.1EW-T1 DIODE MTZJ-T-77-10B DIODE ERC06-15S D502 D503 D504 D505 D506 8-719-908-03 8-719-908-03 8-719-945-80 8-719-312-10 8-719-302-43 DIODE GP08DPKG23 DIODE GP08DPKG23 DIODE ERC06-15S DIODE RU4AM-T3 DIODE RGP10GPKG3 — 60 — 250V 25V 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REMARK REF.NO. PART NO. DESCRIPTION REMARK FUSE D507 D508 D509 D510 D511 8-719-991-33 8-719-991-33 8-719-109-89 8-719-908-03 8-719-302-43 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE MTZJ-T-77-5.6C DIODE GP08DPKG23 DIODE RGP10GPKG23 D512 D513 D514 D515 D516 8-719-073-01 8-719-979-85 8-719-979-85 8-719-073-01 8-719-991-33 DIODE MA111-TX DIODE RGP15GPKG23 DIODE RGP15GPKG23 DIODE MA111-TX DIODE 1SS133T-77 FB501 FB502 FB503 FB600 FB601 1-410-397-21 1-410-397-21 1-410-397-21 1-412-911-11 1-412-911-11 FERRITE FERRITE FERRITE FERRITE FERRITE 1.1µH 1.1µH 1.1µH 0µH 0µH D517 D518 D519 D520 D521 8-719-991-33 8-719-921-63 8-719-302-43 8-719-073-01 8-719-991-33 DIODE 1SS133T-77 DIODE MTZJ-T-77-7.5X DIODE EL1Z-V1 DIODE MA111-TX DIODE 1SS133T-77 D522 D601 D602 D603 D604 8-719-073-01 8-719-991-33 8-719-991-33 8-719-982-26 8-719-028-72 DIODE MA111-TX DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE MTZJ-T-77-33B DIODE RGP02-17PKG23 FB602 FB603 FB604 FB605 FB606 FB609 FB610 1-412-911-11 1-412-911-11 1-412-911-11 1-412-911-11 1-412-911-11 1-412-911-11 1-412-911-11 FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE FERRITE 0µH 0µH 0µH 0µH 0µH 0µH 0µH D605 D606 D607 D608 D610 8-719-510-53 8-719-108-18 8-719-991-33 8-719-110-53 8-719-510-02 DIODE D4SB60L-F DIODE TF541M DIODE 1SS133T-77 DIODE MTZJ-T-77-20B DIODE D1NS4-TA D611 D612 D613 D614 D615 8-719-063-70 8-719-110-17 8-719-063-70 8-719-063-70 8-719-312-10 DIODE D1NL20U-TA DIODE MTZJ-T-77-10B DIODE D1NL20U-TA DIODE D1NL20U-TA DIODE RU4AM-T3 D616 D617 D618 D619 D620 8-719-510-37 8-719-110-31 8-719-991-33 8-719-110-17 8-719-510-37 DIODE D5LC20U DIODE MTZJ-T-77-12C DIODE 1SS133T-77 DIODE MTZJ-T-77-10B DIODE D5LC20U D622 D623 D624 D625 D626 8-719-077-76 8-719-948-45 8-719-991-33 8-719-991-33 8-719-063-70 DIODE D2SB60A-F04 DIODE ERA22-08TP3 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE D1NL20U-TA D627 D628 D2001 D2002 D2003 D2004 D2005 8-719-110-03 8-719-510-48 8-719-070-80 8-719-110-17 8-719-108-12 8-719-921-44 8-719-921-44 DIODE MTZJ-T-77-7.5A DIODE D1N20R-TA DIODE LNK0120022G DIODE MTZJ-T-77-10B DIODE RD9.1EW-T1 DIODE MTZJ-T-77-5.1C DIODE MTZJ-T-77-5.1C F601 1-576-193-11 FUSE 6.3A/125V FERRITE BEAD IC IC401 IC501 IC502 IC601 IC602 8-759-490-17 8-759-700-07 8-759-192-71 8-749-015-61 8-749-016-47 IC TDA7057AQ/N2 IC NJM2903M-TE2 IC STV9379 IC STR-F6626 IC EA135-F12 IC603 IC604 IC2001 8-759-198-03 IC PQ09RF21 8-759-701-75 IC NJM7805FA 8-742-212-20 HYB IC SBX3081-71 JACK J201 J202 J203 J205 J206 J402 1-794-119-11 1-794-267-11 1-794-118-11 1-794-116-11 1-794-117-11 1-794-116-11 TERMINAL BLOCK, S 4P JACK, PIN 3P JACK BLOCK, PIN 3P JACK BLOCK, PIN 2P JACK BLOCK, PIN 3P JACK BLOCK, PIN 2P CHIP CONDUCTOR JR001 JR002 JR402 JR403 JR411 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT JR472 JR502 JR503 JR505 JR522 JR523 JR526 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT SHORT SHORT — 61 — 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION JR527 1-216-295-91 SHORT REMARK L101 L102 L103 L501 L502 1-412-029-11 1-412-032-11 1-412-029-11 1-409-955-11 1-412-552-11 INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP INDUCTOR INDUCTOR 10µH 100µH 10µH 8mH 2.2mH L503 L504 L505 L506 L507 1-406-677-11 1-412-533-21 1-406-976-11 1-406-677-11 1-412-552-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 10mH 47µH 68µH 10mH 2.2mH L510 L603 L604 L605 1-412-528-11 1-412-529-11 1-412-525-31 1-412-529-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR 18µH 22µH 10µH 22µH PHOTO COUPLER DESCRIPTION REMARK R105 R107 R108 R115 R201 1-216-065-91 1-216-025-91 1-216-025-91 1-216-295-91 1-216-113-00 RES-CHIP RES-CHIP RES-CHIP SHORT RES-CHIP 4.7K 100 100 5% 5% 5% 1/10W 1/10W 1/10W 470K 5% 1/10W R202 R203 R204 R205 R208 1-216-113-00 1-216-022-00 1-216-081-00 1-216-085-00 1-215-924-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL OXIDE 470K 75 22K 33K 15K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 3W R211 R214 R215 R235 R237 1-216-022-00 1-216-113-00 1-216-113-00 1-216-113-00 1-216-033-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 75 470K 470K 470K 220 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R238 R239 R411 R412 R413 1-216-033-00 1-216-113-00 1-249-417-11 1-216-113-00 1-216-113-00 RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP 220 470K 1K 470K 470K 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W R414 R420 R421 R422 R429 1-249-417-11 1-208-796-11 1-249-425-11 1-249-389-11 1-216-113-00 CARBON METAL CHIP CARBON CARBON RES-CHIP 1K 3.9K 4.7K 4.7 470K 5% 0.50% 5% 5% 5% 1/4W 1/10W 1/4W 1/4W 1/10W R430 R431 R433 R436 R437 1-216-049-91 1-216-049-91 1-216-113-00 1-216-065-91 1-216-065-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 1K 1K 470K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R438 R439 R440 R441 R442 1-216-065-91 1-216-065-91 1-216-097-91 1-216-081-00 1-216-025-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 4.7K 4.7K 100K 22K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R445 R446 R447 R454 R501 1-216-073-00 1-215-457-00 1-216-065-91 1-216-025-91 1-249-425-11 RES-CHIP METAL RES-CHIP RES-CHIP CARBON 10K 33K 4.7K 100 4.7K 5% 1% 5% 5% 5% 1/10W 1/4W 1/10W 1/10W 1/4W R502 R503 R505 R506 R507 R508 R509 R510 1-216-455-21 1-249-425-11 1-249-401-11 1-215-883-11 1-260-328-11 1-249-433-11 1-215-891-11 1-249-411-11 METAL OXIDE CARBON CARBON METAL OXIDE CARBON CARBON METAL OXIDE CARBON 560 4.7K 47 33 1K 22K 680 330 5% 5% 5% 5% 5% 5% 5% 5% 2W 1/4W 1/4W 2W 1/2W 1/4W 2W 1/4W 8-749-010-64 PHOTO COUPLER PC123FY2 IC LINK PS401 PART NO. RESISTOR COIL PH601 REF.NO. Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. 1-576-336-21 LINK, IC TRANSISTOR Q101 Q410 Q411 Q501 Q502 8-729-422-27 8-729-422-27 8-729-216-22 8-729-140-50 8-729-045-26 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SC3209LK-TP TRANSISTOR 2SD2580-YB Q503 Q504 Q505 Q506 Q507 8-729-422-27 8-729-809-29 8-729-200-17 8-729-422-27 8-729-216-22 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SC4159-E TRANSISTOR 2SA1091O-TPE2 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX Q601 Q602 Q603 Q604 Q605 8-729-922-37 8-729-423-33 8-729-119-76 8-729-422-27 8-729-046-40 TRANSISTOR 2SD2144S-TP-UVW TRANSISTOR 2SC3311A-QRSTA TRANSISTOR 2SA1309A-QRSTA TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SK2663 Q606 Q607 Q608 Q609 8-729-422-27 8-729-922-37 8-729-422-27 8-729-423-33 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD2144S-TP-UVW TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SC3311A-QRSTA — 62 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. The components identified by in this manual have been carefully factory-selected for each set in order to satisfy regulations regarding x-ray radiation. Should replacement be required, replace only with the value originally used. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION R511 R512 R513 R514 R516 1-249-377-11 1-215-910-00 1-215-905-11 1-216-071-00 1-249-425-11 CARBON METAL OXIDE METAL OXIDE RES-CHIP CARBON 0.47 68 10 8.2K 4.7K 5% 5% 5% 5% 5% R517 R518 R519 R520 R521 1-215-445-00 1-249-427-11 1-215-439-00 1-215-884-11 1-249-413-11 METAL CARBON METAL METAL OXIDE CARBON 10K 6.8K 5.6K 47 470 R522 R523 R524 R525 R526 1-249-417-11 1-216-073-00 1-249-429-11 1-208-804-11 1-208-814-91 CARBON RES-CHIP CARBON METAL CHIP METAL CHIP R528 R529 R530 R532 R533 1-215-429-00 1-216-107-00 1-208-812-11 1-215-437-00 1-215-453-00 R534 R535 R536 R537 R538 1/4W 3W 3W 1/10W 1/4W R565 R566 R567 R568 R569 1-249-429-11 1-216-073-00 1-216-073-00 1-215-882-00 1-214-798-21 CARBON RES-CHIP RES-CHIP METAL OXIDE METAL 10K 10K 10K 22 1.8 5% 5% 5% 5% 1% 1/4W 1/10W 1/10W 2W 1/2W 1% 5% 1% 5% 5% 1/4W 1/4W 1/4W 2W 1/4W R570 R571 R572 R601 R602 1-249-433-11 1-216-065-91 1-216-065-91 1-219-513-11 1-249-389-11 CARBON RES-CHIP RES-CHIP CARBON CARBON 22K 4.7K 4.7K 4.7M 4.7 5% 5% 5% 5% 5% 1/4W 1/10W 1/10W 1/2W 1/4W 1K 10K 10K 8.2K 22K 5% 5% 5% 0.50% 0.50% 1/4W 1/10W 1/4W 1/10W 1/10W R603 R607 R608 R609 R610 1-215-485-00 1-215-859-00 1-240-205-11 1-216-049-91 1-216-073-00 METAL METAL OXIDE CARBON RES-CHIP RES-CHIP 470K 22 22M 1K 10K 1% 5% 5% 5% 5% 1/4W 1W 1/2W 1/10W 1/10W METAL RES-CHIP METAL CHIP METAL METAL 2.2K 270K 18K 4.7K 22K 1% 5% 0.50% 1% 1% 1/4W 1/10W 1/10W 1/4W 1/4W R611 R612 R613 R614 R616 1-216-089-91 1-216-045-00 1-219-512-11 1-249-413-11 1-260-302-51 RES-CHIP RES-CHIP CARBON CARBON CARBON 47K 680 2.2M 470 6.8 5% 5% 5% 5% 5% 1/10W 1/10W 1/2W 1/4W 1/2W 1-215-457-00 1-249-441-11 1-214-798-21 1-249-401-11 1-215-889-00 METAL CARBON METAL CARBON METAL OXIDE 33K 100K 1.8 47 330 1% 5% 1% 5% 5% 1/4W 1/4W 1/2W 1/4W 2W R617 R618 R619 R620 R621 1-216-009-91 1-249-440-11 1-249-437-11 1-249-417-11 1-240-251-11 RES-CHIP CARBON CARBON CARBON CEMENTED 22 82K 47K 1K 6.8 5% 5% 5% 5% 5% 1/10W 1/4W 1/4W 1/4W 10W R539 R540 R541 R543 R544 1-249-385-11 1-215-445-00 1-249-429-11 1-247-887-00 1-249-377-11 CARBON METAL CARBON CARBON CARBON 2.2 10K 10K 220K 0.47 5% 1% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R622 R623 R624 R625 R626 1-249-441-11 1-260-324-11 1-249-429-11 1-249-437-11 1-220-926-11 CARBON CARBON CARBON CARBON FUSIBLE 100K 470 10K 47K 0.47 5% 5% 5% 5% 10% 1/4W 1/2W 1/4W 1/4W 1/2W R545 R546 R547 R548 R549 1-215-873-00 1-249-377-11 1-216-455-21 1-216-377-11 1-260-288-11 METAL OXIDE CARBON METAL OXIDE METAL OXIDE CARBON 4.7K 0.47 560 4.7 0.47 5% 5% 5% 5% 5% 1W 1/4W 2W 2W 1/2W R627 R630 R632 R633 R634 1-215-483-00 1-249-421-11 1-217-611-00 1-249-415-11 1-216-073-00 METAL CARBON METAL CARBON RES-CHIP 390K 2.2K 0.1 680 10K 1% 5% 10% 5% 5% 1/4W 1/4W 2W 1/4W 1/10W R550 R551 R553 R554 R555 1-260-288-11 1-215-907-11 1-216-363-00 1-249-429-11 1-247-895-91 CARBON METAL OXIDE METAL OXIDE CARBON CARBON 0.47 22 0.33 10K 470K 5% 5% 5% 5% 5% 1/2W 3W 2W 1/4W 1/4W R635 R638 R639 R640 R641 1-216-057-00 1-249-399-11 1-249-421-11 1-249-417-11 1-216-369-00 RES-CHIP CARBON CARBON CARBON METAL OXIDE 2.2K 33 2.2K 1K 1 5% 5% 5% 5% 5% 1/10W 1/4W 1/4W 1/4W 2W R556 R557 R558 R559 R560 1-249-417-11 1-247-895-91 1-216-097-91 1-216-073-00 1-215-902-11 CARBON CARBON RES-CHIP RES-CHIP METAL OXIDE 1K 470K 100K 10K 47K 5% 5% 5% 5% 5% 1/4W 1/4W 1/10W 1/10W 1W R642 R643 R644 R645 R646 1-216-089-91 1-249-419-11 1-247-843-11 1-215-898-11 1-249-419-11 RES-CHIP CARBON CARBON METAL OXIDE CARBON 47K 1.5K 3.3K 10K 1.5K 5% 5% 5% 5% 5% 1/10W 1/4W 1/4W 2W 1/4W R561 R562 R563 R564 1-249-406-11 1-208-808-11 1-249-433-11 1-208-824-11 CARBON METAL CHIP CARBON METAL CHIP 120 12K 22K 56K 5% 0.50% 5% 0.50% 1/4W 1/10W 1/4W 1/10W R648 R649 R650 R651 1-215-908-00 1-249-417-11 1-216-387-11 1-249-429-11 METAL OXIDE CARBON METAL OXIDE CARBON 33 1K 0.68 10K 5% 5% 5% 5% 3W 1/4W 3W 1/4W — 63 — REMARK 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. R653 R655 R656 R658 R659 1-216-049-91 1-216-049-91 1-249-429-11 1-216-387-11 1-215-857-11 RES-CHIP RES-CHIP CARBON METAL OXIDE METAL OXIDE 1K 1K 10K 0.68 10 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 3W 1W R660 R661 R663 R2001 R2002 1-215-924-00 1-216-057-00 1-216-081-00 1-216-057-00 1-216-053-00 METAL OXIDE RES-CHIP RES-CHIP RES-CHIP RES-CHIP 15K 2.2K 22K 2.2K 1.5K 5% 5% 5% 5% 5% 3W 1/10W 1/10W 1/10W 1/10W R2003 R2004 R2005 R2007 1-249-425-11 1-216-069-00 1-216-295-91 1-249-413-11 CARBON RES-CHIP SHORT CARBON 4.7K 6.8K 5% 5% 1/4W 1/10W 470 5% 1/4W PART NO. DESCRIPTION REMARK TUNER TU101 8-598-542-00 TUNER, FSS BTF-WA412 VARISTOR VDR601 1-803-585-11 VARISTOR ENE271D-10A * A-1332-061-A CA (VAR) MOUNTED PC BOARD CAPACITOR RELAY RY601 RY602 Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. 1-755-198-11 RELAY 1-755-266-11 RELAY, AC POWER C701 C702 C703 C704 C705 1-104-664-11 1-136-165-00 1-104-664-11 1-107-651-11 1-107-652-11 ELECT MYLAR ELECT ELECT ELECT 47µF 0.1µF 47µF 4.7µF 10µF 20% 5% 20% 20% 20% C707 C708 C709 C710 1-162-114-00 1-136-165-00 1-126-934-11 1-126-964-11 CERAMIC MYLAR ELECT ELECT 0.0047µF 2KV 0.1µF 5.% 220µF 20% 10µF 20% 25V 50V 25V 250V 250V SWITCH S2007 S2008 1-762-816-11 SWITCH, TACTILE 1-762-816-11 SWITCH, TACTILE SWITCH SW501 SW502 1-572-707-11 SWITCH, LEVER 1-572-707-11 SWITCH, LEVER TRANSFORMER T501 T503 T504 T505 T601 1-437-195-11 1-426-981-11 1-435-098-11 1-453-338-11 1-433-900-11 TRANSFORMER, HORIZONTAL DRIVE TRANSFORMER, FERRITE (PMT) TRANSFORMER, HORIZONTAL LINEAR FBT ASSY, NX-4600//X4J4 TRANSFORMER, LINE FILTER T602 T603 T604 1-433-900-11 TRANSFORMER, LINE FILTER 1-435-403-11 TRANSFORMER, CONVERTER (S.R.T) 1-431-852-11 TRANSFORMER, CONVERTER (SRT) CONNECTOR CN701 * 1-564-506-11 PLUG, CONNECTOR 3P CN702 1-695-915-11 TAB (CONTACT) CN704 1-695-915-11 TAB (CONTACT) CN706 * 1-564-509-11 PLUG, CONNECTOR 6P DIODE D701 D702 D703 D704 8-719-901-83 8-719-901-83 8-719-901-83 8-719-302-43 DIODE 1SS83TD DIODE 1SS83TD DIODE 1SS83TD DIODE RGP10GPKG23 IC THERMISTOR TH501 TH601 1-800-193-00 THERMISTOR 1-803-586-11 THERMISTOR, NTC IC701 IC702 8-759-803-42 IC LA6500-FA 8-759-562-43 IC TDA6108JF/N1B JACK THERMISTOR THP601 J701 1-803-540-11 THERMISTOR — 64 — 1-451-470-21 SOCKET, CRT 50V 16V 50V 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REMARK COIL L701 1-408-613-31 INDUCTOR 68µH TRANSISTOR Q700 Q701 8-729-423-33 TRANSISTOR 2SC3311A-QRSTA 8-729-423-33 TRANSISTOR 2SC3311A-QRSTA RESISTOR R700 R701 R702 R703 R704 1-249-433-11 1-249-429-11 1-249-409-11 1-247-807-31 1-249-421-11 CARBON CARBON CARBON CARBON CARBON 22K 10K 220 100 2.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R705 R706 R707 R708 R709 1-249-429-11 1-249-381-11 1-249-383-11 1-247-807-31 1-247-807-31 CARBON CARBON CARBON CARBON CARBON 10K 1 1.5 100 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R710 R711 R712 R713 R714 1-247-807-31 1-260-099-11 1-260-099-11 1-260-099-11 1-260-087-11 CARBON CARBON CARBON CARBON CARBON 100 1K 1K 1K 100 5% 5% 5% 5% 5% 1/4W 1/2W 1/2W 1/2W 1/2W R715 R716 R718 R719 R720 R721 1-260-132-11 1-260-123-11 1-216-373-11 1-215-888-00 1-249-421-11 1-249-421-11 CARBON CARBON METAL OXIDE METAL OXIDE CARBON CARBON 560K 100K 2.2 220 2.2K 2.2K 5% 5% 5% 5% 5% 5% 1/2W 1/2W 2W 2W 1/4W 1/4W VARIABLE RESISTOR RV701 REF.NO. PART NO. DESCRIPTION REMARK C808 C809 C810 C812 C814 1-163-021-91 1-110-501-11 1-130-495-00 1-163-021-91 1-163-021-91 CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP 0.01µF 0.33µF 0.1µF 0.01µF 0.01µF 10% 10% 5% 10% 10% 50V 16V 50V 50V 50V C815 C816 C817 C818 C820 1-129-718-00 1-102-244-00 1-129-928-00 1-164-625-11 1-109-954-11 FILM CERAMIC FILM CERAMIC ELECT 0.022µF 220PF 0.0027µF 680PF 0.47µF 5% 10% 10% 10% 20% 630V 500V 630V 500V 160V C821 C823 C824 C825 C826 C862 1-163-021-91 1-130-967-00 1-104-760-11 1-137-150-11 1-163-251-11 1-126-964-11 CERAMIC CHIP FILM CERAMIC CHIP MYLAR CERAMIC CHIP ELECT 0.01µF 10% 0.0027µF 5% 0.047µF 10% 0.01µF 5% 100PF 5% 10µF 20% CONNECTOR CN800 * 1-564-510-11 PLUG, CONNECTOR 7P CN801 * 1-564-507-11 PLUG, CONNECTOR 4P CN802 * 1-508-784-21 PIN, CONNECTOR (5MM PITCH) 1P DIODE D801 D802 D808 D809 D810 8-719-109-89 8-719-991-33 8-719-991-33 8-719-110-41 8-719-970-87 DIODE MTZJ-T-77-5.6C DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE MTZJ-T-77-15B DIODE ERA38-06TP1 D811 D812 D813 D814 8-719-970-87 8-719-300-33 8-719-991-33 8-719-991-33 DIODE ERA38-06TP1 DIODE ERB44-06TP1 DIODE 1SS133T-77 DIODE 1SS133T-77 1-241-656-11 RES, ADJ, METAL FILM 110M IC IC801 IC802 IC803 * A-1343-874-A 8-759-700-42 IC NJM2904D 8-759-659-67 IC NJM2903D 8-759-659-67 IC NJM2903D CHIP CONDUCTOR D (VAR) MOUNTED PC BOARD JR801 1-216-295-91 SHORT CAPACITOR C801 C802 C803 C804 C807 1-126-960-11 1-126-964-11 1-136-191-11 1-136-191-11 1-163-021-91 ELECT ELECT MYLAR MYLAR CERAMIC CHIP 1µF 10µF 0.22µF 0.22µF 0.01µF 20% 20% 5% 5% 10% 50V 50V 63V 63V 50V COIL L803 — 65 — 1-406-677-11 INDUCTOR 10mH 50V 50V 50V 50V 50V 50V 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK TRANSISTOR Q801 Q802 Q803 Q804 Q805 8-729-422-27 8-729-216-22 8-729-216-22 8-729-216-22 8-729-140-97 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SD601A-QRS-TX 2SB709A-QRS-TX 2SB709A-QRS-TX 2SB709A-QRS-TX 2SB734-T-34 Q806 Q809 Q810 Q811 Q812 8-729-422-27 8-729-422-27 8-729-043-95 8-729-119-76 8-729-119-76 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SD601A-QRS-TX 2SD601A-QRS-TX 2SC3840K 2SA1309A-QRSTA 2SA1309A-QRSTA RESISTOR R801 R802 R803 R804 R805 1-216-089-91 1-216-073-00 1-216-081-00 1-216-073-00 1-216-065-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 47K 10K 22K 10K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R806 R807 R808 R809 R811 1-216-081-00 1-216-061-00 1-216-073-00 1-216-081-00 1-216-025-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 22K 3.3K 10K 22K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R812 R813 R814 R815 R816 1-216-061-00 1-216-041-00 1-215-862-11 1-215-862-11 1-247-807-31 RES-CHIP RES-CHIP METAL OXIDE METAL OXIDE CARBON 3.3K 470 68 68 100 5% 5% 5% 5% 5% 1/10W 1/10W 1W 1W 1/4W R817 R819 R820 R821 R822 1-208-822-11 1-216-089-91 1-208-818-11 1-216-061-00 1-216-065-91 METAL CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP 47K 47K 33K 3.3K 4.7K 0.50% 5% 0.50% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R823 R824 R825 R827 R828 1-216-065-91 1-208-830-11 1-208-830-11 1-216-065-91 1-216-085-00 RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 4.7K 100K 100K 4.7K 33K 5% 0.50% 0.50% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R829 R830 R831 R832 R833 1-208-846-11 1-216-295-91 1-216-049-91 1-216-061-00 1-216-689-11 METAL CHIP SHORT RES-CHIP RES-CHIP RES-CHIP 470K 0.50% 1/10W 1K 3.3K 39K 5% 5% 5% 1/10W 1/10W 1/10W R834 R835 R836 R837 R838 R839 1-216-065-91 1-216-057-00 1-216-057-00 1-208-808-11 1-247-807-31 1-216-025-91 RES-CHIP RES-CHIP RES-CHIP METAL CHIP CARBON RES-CHIP 4.7K 2.2K 2.2K 12K 100 100 5% 5% 5% 0.50% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/4W 1/10W Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REF.NO. PART NO. DESCRIPTION REMARK R841 R842 R845 R846 R847 1-208-806-11 1-208-796-11 1-249-441-11 1-249-441-11 1-249-441-11 METAL CHIP METAL CHIP CARBON CARBON CARBON 10K 3.9K 100K 100K 100K 0.50% 0.50% 5% 5% 5% 1/10W 1/10W 1/4W 1/4W 1/4W R848 R849 R850 R851 R852 1-215-894-11 1-216-486-21 1-216-486-21 1-215-922-11 1-215-922-11 METAL OXIDE METAL OXIDE METAL OXIDE METAL OXIDE METAL OXIDE 2.2K 8.2K 8.2K 6.8K 6.8K 5% 5% 5% 5% 5% 2W 3W 3W 3W 3W R854 R855 R857 R860 R862 1-216-067-00 1-216-091-00 1-208-818-11 1-208-806-11 1-216-057-00 RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP 5.6K 56K 33K 10K 2.2K 5% 5% 0.50% 0.50% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R863 R864 R865 R866 R867 1-216-057-00 1-216-033-00 1-216-097-91 1-249-429-11 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP CARBON RES-CHIP 2.2K 220 100K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/4W 1/10W R868 R869 R870 R871 R872 1-216-073-00 1-216-097-91 1-216-057-00 1-215-489-00 1-216-121-91 RES-CHIP RES-CHIP RES-CHIP METAL RES-CHIP 10K 100K 2.2K 680K 1M 5% 5% 5% 1% 5% 1/10W 1/10W 1/10W 1/4W 1/10W R873 R874 R875 R890 1-216-073-00 1-216-037-00 1-216-035-00 1-216-097-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP 10K 330 270 100K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W TRANSFORMER T801 1-424-584-11 TRANSFORMER, DYNAMIC FOCUS * A-1372-817-A HX MOUNTED PC BOARD CONNECTOR CN4001* 1-564-518-11 PLUG, CONNECTOR 3P RESISTOR R4001 R4002 R4003 — 66 — 1-216-025-91 RES-CHIP 1-216-045-00 RES-CHIP 1-216-047-91 RES-CHIP 100 680 820 5% 5% 5% 1/10W 1/10W 1/10W 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION R4004 R4005 1-216-057-00 RES-CHIP 1-216-069-00 RES-CHIP Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REMARK 2.2K 6.8K 5% 5% REF.NO. 1/10W 1/10W PART NO. DESCRIPTION REMARK CONNECTOR CN402 * 1-564-506-11 PLUG, CONNECTOR 3P CN450 1-573-301-21 CONNECTOR, BOARDTO BOARD 20P SWITCH S4001 S4002 S4003 S4004 S4005 S4006 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 * A-1380-632-A IC SWITCH, TACTILE SWITCH, TACTILE SWITCH, TACTILE SWITCH, TACTILE SWITCH, TACTILE SWITCH, TACTILE IC404 8-759-658-01 IC NJW1130G-TE2 CHIP CONDUCTOR K (VAR) MOUNTED PC BOARD CAPACITOR C201 C202 C404 C405 C406 1-126-963-11 1-126-963-11 1-164-182-11 1-163-034-00 1-163-011-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 4.7µF 20% 4.7µF 20% 0.0033µF 10% 0.033µF 0.0015µF 10% 50V 50V 50V 50V 50V C407 C408 C409 C410 C411 1-164-222-11 1-164-222-11 1-163-011-11 1-163-034-00 1-164-182-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.22µF 0.22µF 0.0015µF 10% 0.033µF 0.0033µF 10% 25V 25V 50V 50V 50V C412 C413 C414 C415 C416 1-163-038-91 1-126-963-11 1-126-963-11 1-126-963-11 1-126-963-11 CERAMIC CHIP ELECT ELECT ELECT ELECT 0.1µF 4.7µF 4.7µF 4.7µF 4.7µF 25V 50V 50V 50V 50V C417 C418 C419 C422 C423 1-126-963-11 1-163-038-91 1-164-346-11 1-126-963-11 1-126-963-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT 4.7µF 0.1µF 1µF 4.7µF 4.7µF C440 C441 C446 C450 C451 C475 C490 1-163-038-91 1-126-933-11 1-126-933-11 1-126-963-11 1-126-963-11 1-163-038-91 1-216-295-91 CERAMIC CHIP ELECT ELECT ELECT ELECT CERAMIC CHIP SHORT 0.1µF 100µF 100µF 4.7µF 4.7µF 0.1µF 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 50V 25V 16V 50V 50V 25V 16V 16V 50V 50V 25V JR402 JR403 JR404 JR407 JR408 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT JR420 JR421 JR422 JR425 JR426 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT JR427 JR428 JR429 JR474 JR491 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT COIL L410 1-414-271-11 INDUCTOR 47µH TRANSISTOR Q430 Q431 Q432 Q433 8-729-422-27 8-729-422-27 8-729-216-22 8-729-216-22 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX RESISTOR R403 R404 R405 R407 R408 1-216-295-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 SHORT RES-CHIP RES-CHIP RES-CHIP RES-CHIP R409 R410 R431 R432 R433 R434 1-216-025-91 1-216-025-91 1-216-073-00 1-216-073-00 1-216-295-91 1-216-065-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT RES-CHIP — 67 — 100 100 100 100 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 100 100 10K 10K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 4.7K 5% 1/10W 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REF.NO. PART NO. DESCRIPTION R435 R436 R437 R438 1-216-033-00 1-216-065-91 1-216-033-00 1-216-033-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP 220 4.7K 220 220 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W C043 C044 C045 C046 1-163-009-11 1-163-009-11 1-164-161-11 1-104-664-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.001µF 0.001µF 0.0022µF 47µF 10% 10% 10% 20% 50V 50V 50V 25V R442 R443 R444 R445 R446 1-216-033-00 1-216-105-91 1-216-105-91 1-216-105-91 1-216-105-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 220 220K 220K 220K 220K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W C047 C048 C051 C060 C062 1-163-259-91 1-163-259-91 1-126-941-11 1-163-005-11 1-126-959-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT 220PF 220PF 470µF 470PF 0.47µF 5% 5% 20% 10% 20% 50V 50V 25V 50V 50V R455 R456 R468 R469 R470 R477 R478 1-216-081-00 1-216-081-00 1-216-295-91 1-216-295-91 1-216-025-91 1-216-105-91 1-216-105-91 RES-CHIP RES-CHIP SHORT SHORT RES-CHIP RES-CHIP RES-CHIP 22K 22K 5% 5% 1/10W 1/10W 100 220K 220K 5% 5% 5% 1/10W 1/10W 1/10W C063 C064 C070 C071 C076 1-137-194-81 1-163-017-00 1-163-009-11 1-163-009-11 1-163-259-91 MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47µF 0.0047µF 0.001µF 0.001µF 220PF 5% 10% 10% 10% 5% 50V 50V 50V 50V 50V C077 C091 C093 C097 C099 1-163-259-91 1-163-037-11 1-163-259-91 1-163-009-11 1-126-960-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 220PF 0.022µF 220PF 0.001µF 1µF 5% 10% 5% 10% 20% 50V 50V 50V 50V 50V C302 C303 C304 C305 C307 1-163-021-91 1-163-021-91 1-163-021-91 1-126-933-11 1-163-227-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.01µF 0.01µF 0.01µF 100µF 10PF 10% 10% 10% 20% 0.50PF 50V 50V 50V 16V 50V C308 C309 C311 C313 C314 1-163-021-91 1-126-933-11 1-163-123-00 1-163-021-91 1-163-231-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01µF 100µF 180PF 0.01µF 15PF 10% 20% 5% 10% 5% 50V 16V 50V 50V 50V C315 C316 C317 C318 C319 1-104-664-11 1-163-243-11 1-163-021-91 1-163-021-91 1-126-767-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 47µF 47PF 0.01µF 0.01µF 1000µF 20% 5% 10% 10% 20% 25V 50V 50V 50V 16V C320 C321 C322 C323 C324 1-164-005-11 1-164-005-11 1-164-005-11 1-164-004-11 1-163-231-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47µF 0.47µF 0.47µF 0.1µF 15PF 10% 5% 25V 25V 25V 25V 50V C325 C326 C328 C329 C330 1-164-005-11 1-164-004-11 1-164-004-11 1-164-004-11 1-126-960-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.47µF 0.1µF 0.1µF 0.1µF 1µF 10% 10% 10% 20% 25V 25V 25V 25V 50V C331 C332 C334 C335 C336 1-163-021-91 1-163-010-11 1-163-003-11 1-126-963-11 1-104-664-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT 0.01µF 0.0012µF 330PF 4.7µF 47µF 10% 10% 10% 20% 20% 50V 50V 50V 50V 25V * A-1304-203-A REMARK Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. MA (VAR) MOUNTED PC BOARD REMARK CAPACITOR C003 C006 C009 C010 C011 1-126-959-11 1-126-964-11 1-163-259-91 1-163-035-00 1-163-259-91 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47µF 10µF 220PF 0.047µF 220PF 20% 20% 5% 5% 50V 50V 50V 50V 50V C012 C015 C016 C017 C019 1-163-009-11 1-163-231-11 1-163-231-11 1-126-960-11 1-163-259-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.001µF 15PF 15PF 1µF 220PF 10% 5% 5% 20% 5% 50V 50V 50V 50V 50V C020 C021 C022 C027 C028 1-163-038-91 1-163-259-91 1-163-135-00 1-163-009-11 1-163-259-91 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1µF 220PF 560PF 0.001µF 220PF 5% 5% 10% 5% 25V 50V 50V 50V 50V C032 C033 C034 C037 C038 1-164-004-11 1-163-259-91 1-163-037-11 1-164-161-11 1-126-941-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.1µF 220PF 0.022µF 0.0022µF 470µF 10% 5% 10% 10% 20% 25V 50V 50V 50V 25V C039 C040 C041 C042 1-126-964-11 1-163-229-11 1-163-237-11 1-163-259-91 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10µF 12PF 27PF 220PF 20% 5% 5% 5% 50V 50V 50V 50V — 68 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REF.NO. PART NO. DESCRIPTION REMARK C338 C339 C340 C341 1-164-004-11 1-126-960-11 1-126-933-11 1-163-233-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP 0.1µF 1µF 100µF 18PF 10% 20% 20% 5% 25V 50V 16V 50V C348 C350 C351 C352 C353 1-164-005-11 1-126-959-11 1-163-021-91 1-163-021-91 1-163-021-91 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47µF 0.47µF 0.01µF 0.01µF 0.01µF 20% 10% 10% 10% 25V 50V 50V 50V 50V C354 C355 C356 C357 C358 1-126-933-11 1-163-021-91 1-164-004-11 1-104-664-11 1-104-664-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT 100µF 0.01µF 0.1µF 47µF 47µF 20% 10% 10% 20% 20% 16V 50V 25V 25V 25V C359 C360 C361 C362 C363 1-163-038-91 1-126-959-11 1-163-038-91 1-104-664-11 1-163-038-91 CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP 0.1µF 0.47µF 0.1µF 47µF 0.1µF C364 C365 C366 C367 C368 1-164-004-11 1-137-194-81 1-163-021-91 1-163-005-11 1-163-021-91 CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1µF 0.47µF 0.01µF 470PF 0.01µF 10% 5% 10% 10% 10% 25V 50V 50V 50V 50V C369 C370 C371 C377 C380 1-163-021-91 1-126-933-11 1-163-243-11 1-126-963-11 1-163-021-91 CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP 0.01µF 100µF 47PF 4.7µF 0.01µF 10% 20% 5% 20% 10% 50V 16V 50V 50V 50V C381 C382 C389 C390 C391 1-163-021-91 1-163-021-91 1-104-760-11 1-163-231-11 1-126-933-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.01µF 0.01µF 0.047µF 15PF 100µF 10% 10% 10% 5% 20% 50V 50V 50V 50V 16V C395 C396 C397 C398 1-163-021-91 1-164-004-11 1-163-021-91 1-126-964-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.01µF 0.1µF 0.01µF 10µF 10% 10% 10% 20% 50V 25V 50V 50V CONNECTOR CN001 CN002 CN003 CN004 CN005 CN006 CN302 CN309 * * * * * * * * 1-564-511-11 1-560-124-00 1-564-512-11 1-564-512-11 1-764-333-11 1-764-333-11 1-564-507-11 1-564-506-11 PLUG, CONNECTOR 8P PLUG, CONNECTOR (2.5MM) 4P PLUG, CONNECTOR 9P PLUG, CONNECTOR 9P PLUG, CONNECTOR 10P PLUG, CONNECTOR 10P PLUG, CONNECTOR 4P PLUG, CONNECTOR 3P 20% 20% REF.NO. 25V 50V 25V 25V 25V PART NO. DESCRIPTION REMARK DIODE D001 D002 D003 D004 D005 8-719-976-99 8-719-110-17 8-719-073-01 8-719-976-99 8-719-109-89 DIODE UDZ-TE-17-5.1B DIODE MTZJ-T-77-10B DIODE MA111-TX DIODE UDZ-TE-17-5.1B DIODE MTZJ-T-77-5.6C D006 D075 D301 D305 D360 8-719-977-22 8-719-073-01 8-719-921-44 8-719-921-44 8-719-914-44 DIODE UDZ-TE-17-9.1B DIODE MA111-TX DIODE MTZJ-T-77-5.1C DIODE MTZJ-T-77-5.1C DIODE DAP202K-T-146 FERRITE BEAD FB001 FB002 FB301 1-414-234-22 INDUCTOR CHIP 1-414-234-22 INDUCTOR CHIP 1-412-911-11 FERRITE FILTER FL301 FL302 FL303 1-239-847-11 FILTER, LOW PASS 1-239-847-11 FILTER, LOW PASS 1-239-847-11 FILTER, LOW PASS IC IC001 IC002 IC003 IC301 IC302 8-759-688-47 8-759-663-29 8-759-527-77 8-752-094-98 8-759-655-75 IC M37280MK-112SP IC MM1476AF(TP) IC M24C16-MN6T IC CXA2154S IC TC90A49P CHIP CONDUCTOR JR001 JR002 JR003 JR005 JR006 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT JR007 JR008 JR010 JR011 JR090 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT JR100 JR101 JR296 JR297 JR298 JR378 JR379 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT SHORT SHORT — 69 — 0µH 0µH 0µH 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION JR391 JR399 JR401 JR402 JR501 JR502 JR503 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 SHORT SHORT SHORT SHORT SHORT SHORT SHORT REMARK REF.NO. Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. PART NO. DESCRIPTION REMARK RESISTOR COIL L002 L003 L040 L301 L302 1-414-273-11 1-414-273-11 1-408-963-11 1-414-267-11 1-414-271-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 100µH 100µH 2.7µH 10µH 47µH L303 L304 L305 L308 L310 L350 L351 1-414-856-11 1-414-856-11 1-414-267-11 1-414-273-11 1-414-273-11 1-414-856-11 1-414-856-11 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 10µH 10µH 10µH 100µH 100µH 10µH 10µH TRANSISTOR Q001 Q002 Q003 Q004 Q006 8-729-216-22 8-729-422-27 8-729-422-27 8-729-216-22 8-729-216-22 TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX Q082 Q302 Q303 Q305 Q310 8-729-422-27 8-729-422-27 8-729-216-22 8-729-216-22 8-729-216-22 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX Q349 Q350 Q351 Q352 Q354 8-729-422-27 8-729-216-22 8-729-216-22 8-729-422-27 8-729-216-22 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX Q355 Q356 Q358 Q359 Q365 8-729-216-22 8-729-422-27 8-729-422-27 8-729-216-22 8-729-422-27 TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SD601A-QRS-TX Q368 Q369 Q370 Q375 Q387 Q388 Q389 8-729-422-27 8-729-216-22 8-729-216-22 8-729-422-27 8-729-216-22 8-729-216-22 8-729-216-22 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB709A-QRS-TX R001 R002 R003 R004 R005 1-216-043-91 1-216-041-00 1-247-807-31 1-216-061-00 1-216-295-91 RES-CHIP RES-CHIP CARBON RES-CHIP SHORT 560 470 100 3.3K 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W R006 R007 R008 R009 R010 1-216-025-91 1-216-025-91 1-216-049-91 1-216-121-91 1-216-033-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 100 1K 1M 220 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R011 R012 R013 R014 R015 1-216-033-00 1-216-045-00 1-249-417-11 1-216-073-00 1-216-073-00 RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP 220 680 1K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W R016 R017 R018 R019 R020 1-216-041-00 1-208-798-11 1-249-409-11 1-216-113-00 1-216-033-00 RES-CHIP METAL CHIP CARBON RES-CHIP RES-CHIP 470 4.7K 220 470K 220 5% 0.50% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W R021 R022 R023 R024 R025 1-249-429-11 1-249-409-11 1-249-429-11 1-249-409-11 1-249-426-11 CARBON CARBON CARBON CARBON CARBON 10K 220 10K 220 5.6K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R026 R027 R028 R029 R030 1-249-426-11 1-249-426-11 1-216-049-91 1-216-065-91 1-216-065-91 CARBON CARBON RES-CHIP RES-CHIP RES-CHIP 5.6K 5.6K 1K 4.7K 4.7K 5% 5% 5% 5% 5% 1/4W 1/4W 1/10W 1/10W 1/10W R031 R032 R033 R034 R035 1-216-355-11 1-216-033-00 1-216-033-00 1-216-033-00 1-216-033-00 METAL OXIDE RES-CHIP RES-CHIP RES-CHIP RES-CHIP 3.3 220 220 220 220 5% 5% 5% 5% 5% 1W 1/10W 1/10W 1/10W 1/10W R036 R037 R038 R039 R040 1-216-049-91 1-249-409-11 1-216-049-91 1-216-045-00 1-249-409-11 RES-CHIP CARBON RES-CHIP RES-CHIP CARBON 1K 220 1K 680 220 5% 5% 5% 5% 5% 1/10W 1/4W 1/10W 1/10W 1/4W R041 R042 R043 R044 R045 1-216-045-00 1-216-071-00 1-249-417-11 1-216-033-00 1-216-065-91 RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP 680 8.2K 1K 220 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W R046 R047 R050 1-216-033-00 RES-CHIP 1-216-065-91 RES-CHIP 1-216-033-00 RES-CHIP 220 4.7K 220 5% 5% 5% 1/10W 1/10W 1/10W — 70 — 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION R051 R052 R054 R055 R056 1-216-033-00 1-249-417-11 1-216-065-91 1-216-065-91 1-208-798-11 RES-CHIP CARBON RES-CHIP RES-CHIP METAL CHIP 220 1K 4.7K 4.7K 4.7K 5% 5% 5% 5% 0.50% R057 R058 R060 R061 R064 1-216-097-91 1-216-097-91 1-249-409-11 1-216-033-00 1-216-295-91 RES-CHIP RES-CHIP CARBON RES-CHIP SHORT 100K 100K 220 220 R070 R071 R073 R074 R077 1-216-065-91 1-216-065-91 1-249-425-11 1-216-065-91 1-216-097-91 RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP R086 R087 R088 R091 R092 1-216-045-00 1-216-045-00 1-216-045-00 1-216-073-00 1-208-798-11 R093 R094 R095 R097 R099 1/10W 1/4W 1/10W 1/10W 1/10W R303 R304 R305 R306 R308 1-216-073-00 1-247-807-31 1-216-295-91 1-216-025-91 1-216-022-00 RES-CHIP CARBON SHORT RES-CHIP RES-CHIP 10K 100 5% 5% 1/10W 1/4W 100 75 5% 5% 1/10W 1/10W 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W R310 R311 R312 R313 R316 1-249-417-11 1-216-025-91 1-249-417-11 1-216-049-91 1-216-067-00 CARBON RES-CHIP CARBON RES-CHIP RES-CHIP 1K 100 1K 1K 5.6K 5% 5% 5% 5% 5% 1/4W 1/10W 1/4W 1/10W 1/10W 4.7K 4.7K 4.7K 4.7K 100K 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W R317 R318 R319 R320 R321 1-247-807-31 1-216-091-00 1-216-081-00 1-216-025-91 1-216-043-91 CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 56K 22K 100 560 5% 5% 5% 5% 5% 1/4W 1/10W 1/10W 1/10W 1/10W RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP 680 680 680 10K 4.7K 5% 5% 5% 5% 0.50% 1/10W 1/10W 1/10W 1/10W 1/10W R322 R323 R324 R326 R327 1-216-025-91 1-216-025-91 1-216-065-91 1-208-806-11 1-216-025-91 RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP 100 100 4.7K 10K 100 5% 5% 5% 0.50% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1-216-065-91 1-216-065-91 1-216-065-91 1-249-414-11 1-216-089-91 RES-CHIP RES-CHIP RES-CHIP CARBON RES-CHIP 4.7K 4.7K 4.7K 560 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/4W 1/10W R328 R329 R331 R332 R333 1-216-025-91 1-216-025-91 1-216-049-91 1-216-022-00 1-216-067-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 100 1K 75 5.6K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R251 R253 R256 R257 R258 1-216-065-91 1-216-049-91 1-216-073-00 1-216-049-91 1-216-065-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 4.7K 1K 10K 1K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R334 R335 R336 R337 R338 1-216-025-91 1-216-057-00 1-216-057-00 1-216-057-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 2.2K 2.2K 2.2K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R259 R260 R261 R262 R263 1-249-429-11 1-249-409-11 1-216-113-00 1-247-807-31 1-216-025-91 CARBON CARBON RES-CHIP CARBON RES-CHIP 10K 220 470K 100 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/10W 1/4W 1/10W R339 R340 R341 R342 R343 1-216-091-00 1-216-025-91 1-216-089-91 1-216-049-91 1-216-097-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 56K 100 47K 1K 100K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R267 R268 R269 R273 R274 1-216-049-91 1-216-045-00 1-216-049-91 1-216-073-00 1-216-295-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT 1K 680 1K 10K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R344 R345 R346 R347 R349 1-216-295-91 1-216-097-91 1-216-097-91 1-216-025-91 1-216-025-91 SHORT RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100K 100K 100 100 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R275 R276 R277 R280 R281 1-216-081-00 1-216-085-00 1-216-133-00 1-216-069-00 1-208-798-11 RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP 22K 33K 3.3M 6.8K 4.7K 5% 5% 5% 5% 0.50% 1/10W 1/10W 1/10W 1/10W 1/10W R351 R352 R353 R354 R355 1-216-041-00 1-247-807-31 1-247-807-31 1-216-025-91 1-216-053-00 RES-CHIP CARBON CARBON RES-CHIP RES-CHIP 470 100 100 100 1.5K 5% 5% 5% 5% 5% 1/10W 1/4W 1/4W 1/10W 1/10W R282 R283 R300 R301 1-208-790-11 1-216-689-11 1-216-295-91 1-216-022-00 METAL CHIP RES-CHIP SHORT RES-CHIP 2.2K 39K 0.50% 1/10W 5% 1/10W 75 5% R356 R357 R358 R359 1-216-025-91 1-216-022-00 1-216-093-91 1-216-057-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 75 68K 2.2K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W — 71 — REMARK 更多难得资料请到江南家电维修论坛免费下载！ http://bbs.520101.com KV-34FS12T Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK R360 R361 R362 R363 R364 1-216-093-91 1-216-022-00 1-216-035-00 1-216-039-00 1-216-025-91 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 68K 75 270 390 100 5% 5% 5% 5% 5% R365 R366 R367 R368 R369 1-216-025-91 1-216-053-00 1-216-057-00 1-216-043-91 1-216-033-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 100 1.5K 2.2K 560 220 R370 R372 R373 R374 R375 1-249-429-11 1-216-043-91 1-216-025-91 1-216-025-91 1-216-053-00 CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP R376 R377 R378 R379 R382 1-216-022-00 1-216-057-00 1-216-295-91 1-216-049-91 1-216-295-91 RES-CHIP RES-CHIP SHORT RES-CHIP SHORT R383 R384 R386 R387 R388 1-216-295-91 1-216-295-91 1-216-047-91 1-216-025-91 1-216-025-91 R389 R392 R394 R395 R396 R398 R399 1-216-049-91 1-216-067-00 1-216-043-91 1-216-043-91 1-247-807-31 1-216-109-00 1-216-689-11 Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REF.NO. PART NO. DESCRIPTION REMARK 1/10W 1/10W 1/10W 1/10W 1/10W C811 C901 C902 C903 C904 1-129-768-61 1-107-667-11 1-130-491-00 1-126-925-11 1-130-471-00 FILM ELECT MYLAR ELECT MYLAR 0.082µF 2.2µF 0.047µF 470µF 0.001µF 5% 20% 5% 20% 5% 200V 160V 50V 10V 50V 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W C905 C906 C907 C908 C909 1-106-383-00 1-130-471-00 1-107-638-11 1-126-925-11 1-161-830-00 MYLAR MYLAR ELECT ELECT CERAMIC 0.047µF 0.001µF 33µF 470µF 0.0047µF 10% 5% 20% 20% 200V 50V 160V 10V 500V 10K 560 100 100 1.5K 5% 5% 5% 5% 5% 1/4W 1/10W 1/10W 1/10W 1/10W C910 C911 C912 C913 C914 1-104-999-11 1-104-665-11 1-126-941-11 1-102-074-00 1-130-491-00 MYLAR ELECT ELECT CERAMIC MYLAR 0.1µF 100µF 470µF 0.001µF 0.047µF 10% 20% 20% 10% 5% 200V 10V 25V 50V 50V 75 2.2K 5% 5% 1/10W 1/10W 1K 5% 1/10W SHORT SHORT RES-CHIP RES-CHIP RES-CHIP 820 100 100 5% 5% 5% 1/10W 1/10W 1/10W RES-CHIP RES-CHIP RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP 1K 5.6K 560 560 100 330K 39K 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/4W 1/10W 1/10W CONNECTOR CN901 * 1-564-508-11 PLUG, CONNECTOR 5P CN902 * 1-770-723-11 CONNECTOR, BOARDTO BOARD 8P CN904 * 1-564-507-11 PLUG, CONNECTOR 4P DIODE D804 D805 D806 D807 D901 D902 D903 8-719-302-43 8-719-991-33 8-719-991-33 8-719-210-21 8-719-110-88 8-719-110-88 8-719-991-33 DIODE RGP10GPKG23 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE ERA82-004TP5 DIODE MTZJ-T-77-39 DIODE MTZJ-T-77-39 DIODE 1SS133T-77 COIL L801 L802 L901 CRYSTAL X001 X301 1-767-487-11 VIBRATOR, CRYSTAL 1-567-505-11 OSCILLATOR, CRYSTAL 1-406-989-21 INDUCTOR 1-459-111-00 INDUCTOR 1-412-528-11 INDUCTOR 10mH 10mH 18µH TRANSISTOR * A-1342-549-A Q807 Q808 Q901 Q902 Q903 Q904 Q905 Q906 VA (VAR) MOUNTED PC BOARD 4-382-854-11 SCREW (M3X10), P, SW (+) CAPACITOR C805 1-130-338-61 FILM 0.01µF 5% 630V — 72 — 8-729-931-45 8-729-140-97 8-729-017-06 8-729-017-05 8-729-423-33 8-729-423-33 8-729-119-76 8-729-423-33 TRANSISTOR IRF614 TRANSISTOR 2SB734-T-34 TRANSISTOR 2SC4793 TRANSISTOR 2SA1837 TRANSISTOR 2SC3311A-QRSTA TRANSISTOR 2SC3311A-QRSTA TRANSISTOR 2SA1309A-QRSTA TRANSISTOR 2SC3311A-QRSTA 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com Note: Note: The components identified by shading and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION Les composants identifies per un trame et une marque sont critiques pour la securite. Ne les remplacer que par une piece portant le numero specifie. REMARK REF.NO. RESISTOR R818 R826 R876 R901 R902 1-216-025-91 1-249-421-11 1-216-049-91 1-249-401-11 1-249-386-11 RES-CHIP CARBON RES-CHIP CARBON CARBON 100 2.2K 1K 47 2.7 5% 5% 5% 5% 5% 1/10W 1/4W 1/10W 1/4W 1/4W R903 R904 R905 R906 R907 1-249-414-11 1-249-432-11 1-249-417-11 1-249-432-11 1-249-386-11 CARBON CARBON CARBON CARBON CARBON 560 18K 1K 18K 2.7 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R908 R909 R910 R911 R912 1-249-414-11 1-260-312-11 1-216-476-11 1-249-403-11 1-249-409-11 CARBON CARBON METAL OXIDE CARBON CARBON 560 47 180 68 220 5% 5% 5% 5% 5% 1/4W 1/2W 3W 1/4W 1/4W R913 R914 R915 R916 R917 1-249-403-11 1-249-410-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 68 270 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R918 R919 R920 R921 R922 R923 1-247-807-31 1-247-807-31 1-249-416-11 1-249-429-11 1-249-397-11 1-249-401-11 CARBON CARBON CARBON CARBON CARBON CARBON 100 100 820 10K 22 47 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W ACCESSORIES AND PACKAGING * * * * 4-077-624-71 4-073-714-03 4-073-715-01 4-073-716-01 4-041-259-01 MANUAL, INSTRUCTION CARTON, INDIVIDUAL CUSHION ASSY, UPPER CUSHION ASSY, LOWER BAG, PROTECTION REMOTE COMMANDER 1-418-387-11 REMOTE COMMANDER (RM-Y168) 4-978-977-01 BATTERY COVER — 73 — PART NO. DESCRIPTION REMARK 更多难得资料请到江南家电维修论坛免费下载！ KV-34FS12T http://bbs.520101.com 9-965-889-01 Sony Corporation English Sony Technology Cente Technical Services Service Promotion Dept. 2000FS74030-1 Printed in USA 2000.6
