Download CPD-E220/E215E/E220E

page
1
page
2
page
3
page
4
page
5
page
6
page
7
page
8
page
9
page
10
page
11
page
12
page
13
page
14
page
15
page
16
page
17
page
18
page
19
page
20
page
21
page
22
page
23
page
24
page
25
page
26
page
27
page
28
page
29
page
30
page
31
page
32
page
33
page
34
Transcript 
CPD-E220/E215E/E220E
[CPD-E220]
SERVICE MANUAL
Equator Model
S. Hemisphere Model
N. Hemisphere Model
Chassis No. SCC-L35B-A
[CPD-E215E]
AEP Model
Chassis No. SCC-L35D-A
[CPD-E220E]
AEP Model
Chassis No. SCC-L35C-A
H1 CHASSIS
SPECIFICATIONS
CRT
Viewable image size
Resolution
Maximum
Recommended
Standard image area
Deflection frequency*
AC input voltage/current
Power consumption
Dimensions
Mass
Plug and Play
0.24 mm aperture grille pitch (center)
17 inches measured diagonally
90-degree deflection
FD Trinitron
Approx. 327 × 243 mm (w/h)
(14 3/4 × 9 5/8 inches)
16.0" viewing image
* Recommended horizontal and vertical timing condition
• Horizontal sync width should be more than 1.0 µsec.
• Horizontal blanking width should be more than 3.0 µsec.
• Vertical blanking width should be more than 500 µsec.
Design and specifications are subject to change without notice.
Horizontal: 1600 dots (E220/E220E)
1280 dots (E215E)
Vertical: 1200 lines (E220/E220E)
1024 lines (E215E)
Horizontal: 1024 dots
Vertical: 768 lines
Approx. 312 × 234 mm (w/h)
(12 3/8 × 9 1/4 inches)
Horizontal: 30 to 85 kHz (E220/E220E)
30 to 70 kHz (E215E)
Vertical: 48 to 120 Hz
220 to 240 V, 50/60 Hz, 0.9 A
120 W
Approx. 404 × 413.5 × 419.5 mm (w/h/
d) (16 × 16 3/8 × 16 5/8 inches)
Approx. 20 kg (44 lb 1 oz)
DDC1/DDC2B/DDC2Bi
TRINITRON COLOR COMPUTER DISPLAY
®
CPD-E220/E215E/E220E
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer:
1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder
splashes and bridges.
2. Check the interboard wiring to ensure that no wires are
“pinched” or contact high-wattage resistors.
3. Check that all control knobs, shields, covers, ground straps,
and mounting hardware have been replaced. Be absolutely
certain that you have replaced all the insulators.
4. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
5. Look for parts which, though functioning, show obvious
signs of deterioration. Point them out to the customer and
recommend their replacement.
6. Check the line cords for cracks and abrasion. Recommend
the replacement of any such line cord to the customer.
7. Check the B+ and HV to see if they are specified values.
Make sure your instruments are accurate; be suspicious of
your HV meter if sets always have low HV.
8. Check the antenna terminals, metal trim, “metallized”
knobs, screws, and all other exposed metal parts for AC
Leakage. Check leakage as described below.
To Exposed Metal
Parts on Set
0.15 µF
1.5 kΩ
AC
Voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500
microampers).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or
RCA WT-540A. Follow the manufacturers’ instructions to
use these instruments.
2. A battery-operated AC milliammeter. The Data Precision
245 digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are
examples of a passive VOMs that are suitable. Nearly all
battery operated digital multimeters that have a 2 V AC
range are suitable. (See Fig. A)
WARNING!!
NEVER TURN ON THE POWER IN A CONDITION IN
WHICH THE DEGAUSS COIL HAS BEEN REMOVED.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY SHADING AND MARK
0 ON THE SCHEMATIC DIAGRAMS, EXPLODED
VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR
SAFE OPERATION. REPLACE THESE COMPONENTS
WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION
ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE
PROCEDURES WHENEVER CRITICAL COMPONENTS
ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED.
AVERTISSEMENT!!
NE JAMAIS METTRE SOUS TENSION QUAND LA
BOBINE DE DEMAGNETISATION EST ENLEVÉE.
ATTENTION AUX COMPOSANTS RELATIFS À LA
SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE TRAME ET
UNE MARQUE 0 SONT CRITIQUES POUR LA SÉCURITÉ.
NE LES REMPLACER QUE PAR UNE PIÈCE PORTANT LE
NUMÉRO SPECIFIÉ. LES RÉGLAGES DE CIRCUIT DONT
L’IMPORTANCE EST CRITIQUE POUR LA SÉCURITÉ DU
FONCTIONNEMENT SONT IDENTIFIÉS DANS LE
PRÉSENT MANUEL. SUIVRE CES PROCÉDURES LORS
DE CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU LORSQU’UN MAUVAIS FONCTIONNEMENT
EST SUSPECTÉ.
–2–
CPD-E220/E215E/E220E
POWER SAVING FUNCTION
This monitor meets the power-saving guidelines set by VESA,
ENERGY STAR, and NUTEK. If the monitor is connected to a
computer or video graphics board that is DPMS (Display Power
Management Signaling) compliant, the monitor will automatically
reduce power consumption in three stages as shown below.
Power mode
Power consumption
1 (power)
indicator
normal
operation
≤ 120 W
green
1 standby
≤ 15 W
green and orange
alternate
2 suspend
(sleep)*
≤ 15 W
green and orange
alternate
3 active off**
(deep sleep)*
≤3W
orange
power off
0W
off
* “Sleep” and “deep sleep” are power saving modes defined by the
Environmental Protection Agency.
** When your computer is in a power saving mode, MONITOR IS IN
POWER SAVE MODE appears on the screen if you press any button
on the monitor. After a few seconds, the monitor enters the power
saving mode again.
DIAGNOSIS
This monitor is equipped with a self-diagnosis function. If there is
a problem with your monitor or computer, the screen will go blank
and the 1 (power) indicator will either light up green or flash
orange. If the 1 (power) indicator is lit in orange, the computer is
in power saving mode. Try pressing any key on the keyboard.
If all four color bars appear (white, red, green, blue), the monitor
is working properly. Reconnect the video input cable and check
the condition of your computer.
If the color bars do not appear, there is a potential monitor failure.
Inform your authorized Sony dealer of the monitor’s condition.
MENU
If the 1 (power) indicator is flashing orange
RESET
1 (power) indicator
If the 1 (power) indicator is green
1 Disconnect the video input cable or turn off the
connected computer.
2 Press the 1 (power) button twice to turn the monitor
off and then on.
Press the 1 (power) button twice to turn the monitor off
and then on.
If the 1 (power) indicator lights up green, the monitor is working
properly.
If the 1 (power) indicator is still flashing, there is a potential
monitor failure. Count the number of seconds between orange
flashes of the 1 (power) indicator and inform your authorized
Sony dealer of the monitor’s condition. Be sure to note the model
name and serial number of your monitor. Also note the make and
model of your computer and video board.
3 Move the control button , for 2 seconds before the
monitor enters power saving mode.
MENU
–3–
CPD-E220/E215E/E220E
TIMING SPECIFICATION
PRIMARY MODE
MODE AT PRODUCTION
MODE 1
MODE 2
MODE 3
MODE 4
MODE 5
MODE 6
MODE 7
MODE 8
640 X 480
800 X 600
832 X 624
1024 X 768
1024 X 768
720 X 400
640 X 480
1280 X 1024
25.175 MHz
56.250 MHz
57.283 MHz
78.750 MHz
94.500 MHz
28.322 MHz
36.000 MHz
135.000 MHz
31.469 kHz
53.674 kHz
49.725 kHz
60.024 kHz
68.677 kHz
31.469 kHz
43.269 kHz
79.976 kHz
usec
usec
usec
usec
usec
usec
usec
usec
H. TOTAL
31.778
18.631
20.111
16.660
14.561
31.777
23.111
12.504
H. BLK
6.356
4.409
5.586
3.657
3.725
6.355
5.333
3.022
H. FP
0.636
0.569
0.559
0.203
0.508
0.636
1.556
0.119
H. SYNC
3.813
1.138
1.117
1.219
1.016
3.813
1.556
1.067
RESOLUTION
CLOCK
— HORIZONTAL —
H-FREQ
H. BP
1.907
2.702
3.910
2.235
2.201
1.907
2.222
1.837
H. ACTIV
25.422
14.222
14.524
13.003
10.836
25.422
17.778
9.481
59.940 Hz
85.061 Hz
74.550 Hz
75.030 Hz
84.997 Hz
70.087 Hz
85.008 Hz
75.025 Hz
lines
lines
lines
lines
lines
lines
lines
lines
V. TOTAL
525
631
667
800
808
449
509
1066
V. BLK
45
31
43
32
40
49
29
42
V. FP
10
1
1
1
1
12
1
1
V. SYNC
2
3
3
3
3
2
3
3
V. BP
33
27
39
28
36
35
25
38
V. ACTIV
480
600
624
768
768
400
480
1024
— VERTICAL —
V. FREQ(HZ)
— SYNC —
INT(G)
EXT(H/V)/POLARITY
EXT(CS)/POLARITY
INT/NON INT
NO
NO
NO
NO
NO
NO
NO
NO
YES -/-
YES +/+
YES -/-
YES +/+
YES +/+
YES -/+
YES -/-
YES +/+
NO
NO
NO
NO
NO
NO
NO
NO
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
NON INT
2000.8.28 VER.
–4–
CPD-E220/E215E/E220E
TABLE OF CONTENTS
Section
Title
Page
1. GENERAL .................................................................. 1-1
2. DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
Cabinet Removal .................................................
A and D Boards Removal ...................................
Service Position ....................................................
Picture Tube Removal ..........................................
H Board Removal .................................................
Harness Location ..................................................
2-1
2-1
2-2
2-2
2-3
2-4
3. SAFETY RELATED ADJUSTMENT ............. 3-1
4. ADJUSTMENTS ...................................................... 4-1
5. DIAGRAMS
5-1.
5-2.
5-3.
5-4.
(1)
(2)
(3)
5-5.
Block Diagrams ................................................... 5-1
Frame Schematic Diagram .................................. 5-5
Circuit Boards Location ...................................... 5-6
Schematic Diagrams and Printed Wiring Boards .. 5-7
Schematic Diagram of H Board ......................... 5-8
Schematic Diagram of A Board ......................... 5-9
Schematic Diagrams of
D (a, b, c, d) Board .................................. 5-13
Semiconductors .................................................. 5-23
6. EXPLODED VIEWS
6-1.
6-2.
6-3.
Chassis ................................................................. 6-1
Picture Tube ........................................................ 6-2
Packing Materials ................................................ 6-3
7. ELECTRICAL PARTS LIST ............................ 7-1
–5–
CPD-E220/E215E/E220E
SECTION 2
DISASSEMBLY
2-1. CABINET REMOVAL
Push in the tip of a screwdriver
about 10mm to unlock the claw.
Cabinet
Cabinet
2
Bezel assembly
Bezel assembly
3
1
Two claws
Cabinet
Two screws
(+BVTP 4 x 16)
2-2. A AND D BOARDS REMOVAL
7
A board
CN309
CN307
CN304
GND
CN303
GND
CN2
CN310
CN302
CN301
GND
9
CN903
CN602
Connector
(2P)
Three screws
(+BVTT 3 x 12)
2
Cable stopper
1
GND
10
Four screws
(+BVTT 3 x 8)
8
12
6
Screw
(+BVTT 3 x 8 )
I/O cable assembly
D board
3
Cable holder
5
Cable
4
2-1
Cable cover
Screw
(+M 4 x 8)
CPD-E220/E215E/E220E
2-3. SERVICE POSITION
A board
1
3
2
2-4. PICTURE TUBE REMOVAL
2
A board
GND
CN307
GND
9
Tention spring
3
8
Degauss coil
10
11
Two screws
(+BVTP 4 x 16)
Neck assembly
Deflection yoke
CN602
5
6
Four screws
(Hexagon)
CN2
Chassis assembly
CN903
Connector
(2P)
1
Anode cap
(See page 2-3.)
4
12
13
Two degauss
coil holder
Two degauss
coil holder
Bezel assembly
Cussion
7
2-2
Picture tube
Two screws
(+BVTT 4 x 8)
CPD-E220/E215E/E220E
2-5. H BOARD REMOVAL
1
Screw
(+BVTP 4 x 16)
2
3
H bracket
Claw
Picture tube
4
5
H board
Menu button
Bezel assembly
Cussion
• REMOVAL OF ANODE-CAP
NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after
removing the anode.
• REMOVING PROCEDURES
c
b
a
Anode Button
1 Turn up one side of the rubber cap in
the direction indicated by the arrow A.
2 Using a thumb pull up the rubber cap
firmly in the direction indicated by the
arrow B.
• HOW TO HANDLE AN ANODE-CAP
1 Don’t scratch the surface of anode-caps with sharp shaped
material!
2 Don’t press the rubber hardly not to damage inside of anodecaps!
A material fitting called as shatter-hook terminal is built in the
rubber.
3 Don’t turn the foot of rubber over hardly!
The shatter-hook terminal will stick out or damage the rubber.
2-3
3 When one side of the rubber cap is
separated from the anode button, the
anode-cap can be removed by turning
up the rubber cap and pulling up it in the
direction of the arrow C.
CPD-E220/E215E/E220E
2-6. HARNESS LOCATION
Degauss coil
H board
Picture tube
CN2
CN1
CN903
CN505
CN901
CN603
D board
CN504
CN501
CN502
CN902
CN602
CN302
AC inlet
CN301
CN304
CN303
CN309
CN310
CN307
A board
2-4
CPD-E220/E215E/E220E
SECTION 3
SAFETY RELATED ADJUSTMENT
8)
When replacing parts shown in the table below, the
following operational checks must be performed as a
safety precaution against X-ray emissions from the unit.
Part Replaced ( ] )
HV Regulator
Circuit
D board
IC502, T501 (FBT)
HV HOLD
DOWN Circuit
D board
D538, R521, T501 (FBT)
Beam Current
Protector Circuit
D board
IC901, R949, T501 (FBT)
After adjusting the High Voltage within specification,
put the VR cover on VR501 as shown below and apply
sufficient amount of RTV around VR501.
b) HV Protector Circuit Check
1) Confirm that the voltage between cathode of D517 an
GND is more than 27.5 VDC.
2) Using an external DC Power supply, apply the voltage
shown below between cathode of D517 on "D" and
GND, and confirm that the HV Hold-Down circuit
works. (Raster disappears) Apply DC Voltage: Less than
35.8 VDC.
Allow the unit to warm up for one minute prior to checking
the following conditions:
Check Condition
• Input voltage
• Input signal
• Controls
• B+ Voltage
a) HV Regulator Check
1) Input white cross hatch signal. (fH = 69 kHz)
2) CONT maximum and BRT center
3) Cut off Screen VR (G2).
4) Input voltage: 120 ± 2 VAC
5) Confirm that the voltage is within the voltage range
shown below.
Standard voltage: 26.9 KV ± 0.4 KV
6) When replacing components identified by ], make sure
to recheck the High Voltage.
7) Verify the High Voltage as shown above (26.9 KV ± 0.4
KV) is within specification. If not, set H. SIZE data at
minimum (-127) and then adjust VR501 on "D" Board.
: 120 ± 2 VAC
: (fH = 69 kHz), White Cross Hatch
: CONT (max) & BRT (center)
: 179 ± 3.0 VDC
c) Beam Protector Check (Software logic)
1) Using an external current source, apply < 1.55mA
between pin qa of FBT (T501) and GND, and confirm
that the raster fades out.
Check Condition
• Input voltage
• Input signal
• Controls
: 120 ± 2 VAC
: (fH = 69 kHz), White Cross Hatch
: CONT (max) & BRT (center)
d) B+ Voltage Check
1) Input white cross hatch (fH = 69 kHz) signal.
2) CONT (max) & BRT (center)
3) Input voltage: 120 ± 2 VAC
Note: Use NF power supply or make sure that distortion
factor is 3% or less.
4) Confirm that the voltage is within the voltage range
shown below.
Standard voltage: 179 ± 3.0 VDC
VR501
3-1
CPD-E220/E220E/E215E
#2 SECTION 4
ADJUSTMENTS
Connect the communication cable of the computer to the connector located on the monitor. Run the service software and then follow
the instruction.
I2C Interface Card
I2 C Interface Cable
HD15 Connector Adapter
Computer
as a Jig
Video Cable
• Landing Fine Adjustment
1.
2.
3.
4.
Put the set inside the Helmholtz coil.
Set TLH plate to zero position.
Input the single green signal.
Demagnetize the CRT surface with the hand degausser , and
perform auto degaussing.
5. Attach the wobbling coil to the designated part of the CRT
neck.
6. Attach the sensor of the landing adjustment unit on the CRT
surface.
Purity magnet position
L/D control specification
±5
±5
±5
a
d
±5
±5
±5
(µm)
10. If the corner landing is out of specification, put a disk magnet for the landing correction.
11. Perform auto degauss in case disk magnets are used.
12. Remove the sensor and wobbling coil.
13. Fix purity magnet on DY with UL black tape.
7. Adjust the DY position and purity, and the DY tilt.
8. Fasten DY with screw.
Note: Torque 20 +2
-1 kgcm
9. Adjust top and bottom pins by pitching DY up and down
with two wedges.
Also leave the yaw of DY to physical center position with
Another two wedes.
c
±7
±7
±7
“a” and “b” must be equal, and
“c” and “d” must be equal.
b
<How to drive in wedges>
4-1
CPD-E220/E220E/E215E
• Convergence Specification
• Convergence Rough Adjustment
1. Enter the crosshatch signal.
2. Recheck focus and readjust when focus was worse.
3. Adjust roughly H. STAT and V. STAT convergence by 4
pole magnet.
4. Adjust roughly HMC and VMC by 6 pole magnet.
B
• Convergence Adjustment
1. Open H and V Stat by 4 pole magnet.
2. Adjust 6 pole magnet perform HMC and VMC.
3. Adjust 4 pole magnet close both Stat of R.G.B just overlap
each other Horizontal and Vertical.
4. Adjust TLH for side MC by TLH magnet when R or B is in
the opposite direction.
5. Adjust XCV to correct Vertical cross MC.
6. Adjust XBV to correct Vertical bow MC.
7. Adjust TLV to corect Vertical tilt MC.
8. Adjust YCH to correct top and bottom Horizontal cross MC.
9. Adjust YBH to correct top and bottom Horizontal bow MC.
10. Using permalloys to correct MC of the cornters.
11. Check convergence for whole screen. If necessary, perform
step from 3-9 and correct with permalloys.
12. Paint lock 4 pole magnet, 6 poles magnets, XBV reactor
XCV corrector and TLH corrector handle.
A
0.30 mm
B
0.35 mm
• Vertical and Horizontal Position and Size
Specification
A
b
B
Purity Mg.
All mode
• White Balance Adjustment Specification
(1) 9300K
(2) 6500K
x = 0.283 ± 0.01
x = 0.313 ± 0.01
y = 0.298 ± 0.01
y = 0.329 ± 0.01
(2) 5000K
x = 0.346 ± 0.01
y = 0.359 ± 0.01
a
6Pole Mg
MODE
A
TLH
MODE
All mode
A
312 mm
B
234 mm
XCV
a
b
YV
YCH
CRT
DY
1.5 mm
1.5 mm
• Focus adjustment
Adjust the focus volume 1 and 2 for the optimum focus.
4Pole Mg
XCV
XBV
YCH
B
R
TLV
R
B
YBH
TLH
R
B
B
R
Focus 1
(V)
Focus 2
(H)
B
R
R
B
B
R
R
B
FBT
4-2
A
C
D
TO D BOARD
CN903
TO D BOARD
CN902
TO D BOARD
CN603
11
12
13
14
15
B
6
7
8
9
10
TO D BOARD
CN901
1
2
3
4
5
SIGNAL-IN
HD15
PIG-TAIL
P701
MENU
ORANGE/LED
GREEN/LED
ABL
+5V
+6.3V
+12V
+81V
CN303
CN302
CLAMP
SDA/I
SCL/I
H_RTN
V_RTN
G1
CN301
RED
GREEN
BLUE
5-1. BLOCK DIAGRAMS
1
2
3
5
6
4
3
1
H
7
8
9
3
4
5
2
4
6
LED701
POWER
5-1
SW701
MENU
CLAMP AMP
Q001,002
SONG BUFF
Q008
(VIDEO, RGB OUT)
(USER CONTROL)
+5V
+6.3V
+12V
+81V
A
DIAGRAMS
SECTION 5
15 ABL IN
27 BLK
21 SDA
20 SCL
19 CLAMP
7 SOGI
2 R IN
6 G IN
11 B IN
6
17 P5/B
18 HOR
19 VERT
H SYNC
BUFF
Q003
V SYNC
BUFF
Q005
5 SCK
6 SIN
12 P0/BK0
15 P3/G
OSD BLKIN 1
P6 9
P7 10
P2 14
P4 16
D105
D205
D305
G2 CONT
Q004
B VOUT1 1
G VOUT3 5
R VOUT2 3
IC003 OSD
OSDB 13
7
OSDG 9
–
+
13 P1/R
5
IC004 AMP
R CUT-OFF
Q101
G CUT-OFF
Q201
OSDR 4
DA1 26
DA2 25
DA3 24
DA4 23
11 B VIN1
B OUT 29
B CUT-OFF
Q301
8 G VIN3
9 R VIN2
IC002
RGB OUT
G OUT 32
R OUT 35
IC001 PRE AMP,OSD MIX
B-SS3562<NH.>-BD1-EPS05
2
1
4
3
1
CN304
CS0
CS1
CS2
CS3
CN309
1.2kV
R.G.B
G1
G2
5-2
CRT
F
E
TO
D BOARD
FBT
TO
D BOARD
FBT
TO
D BOARD
FBT
TO D BOARD
CN502
TO D BOARD
CN504
FV1
FV2
HV
B
D
TO A BOARD
CN302
TO H BOARD
P701
DGC
A
TO VIDEO CABLE
2
3
1
CN903
ORANGE/LED
GREEN/LED
MENU
DGC
NC
DGC
CN602
1
2
3
6
2
1
7
5
V_RTN
SDA/I
SCL/I
H_RTN
G1
AC-SOCKET
3
CN901
CLAMP
CN601
1
3
4
5
6
CN902
H-IN
V-IN
PCDET
SDA
SCL
TH602
F601
S601
POWER
RELAY DRIVE
Q615
RY601
LF601
LFT
SW901
RESET
#3 E220, E220E
#3 E215E
+5V
OUT 3
IC606
TH601
K
G
K
A
G
D601
AC RECT
IC604
A
TEST 7
SDA 5
SCL 6
IC902
EEP ROM
H_RETURN
ABL/O
H SYNC BUFF
Q902
1 IN
IC903
RESET
PB0/SCLD
PD6/CLAMPOUT
PB1/SDAD
VSYNCI
5-3
D610
L606
PC3/PWM3 4
PA2/TDO 38
PC7/PWM7 8
PS5/PWM5 6
D627
SW
Q401
2
FB
COMP
V AEF
1
OSC
4
I SENSE
OUT
Vcc
IC601
PWM CONTROL
8
D623
T601
#3 E220 [NH], E220E, E215E
PA4 36
PA5 35
PB6/AIN2/PWM0 10
PB7/AIN3/PWM1 9
PC4/PWM4 5
PA7/BLANKOUT 31
D609
SW
Q601
SW
Q611
JW106
OSCIN 33
OSCOUT 32
3
6
7
FB603
SWITCHING
Q602
JW105
#3 E220 [SH, EQ]
D626
BOP CONT
Q532,535
19 SDA
18 SCL
D604
1
9
3
Q531
Q532,535
+12V
IC 501
DEFLECTION
CONTROL
17 HUNLOCK
15 HSYNC
PD4/ITB 24
14 VSYNC
16 CLBL
PD0/V SYNCO 20
X901
24MHz
BUFF
Q526
PD1/H SYNCO 21
PA6 34
PD3/ITA/VFBACK 23
#3 E220 [SH, EQ]
7 PS6/PWM6
37 PA3
12 PB4/AIN0
42 PA0/OCMP
39 PA1/RDI
29 PB2/SCU
1 PC0/HSYNCDIV
30 PB3/SDAI
25 PD5/HFBACK
11 PB5/AIN1
19
26
28
27
18 HSYNCI
40 Reset
IC901 CPU
8
H DRIVE
Q520,521
18
17
16
13
12
10
D618
D622
D617
K
+5V
D615
D628
D616
D631
D613
7 +V IN
IC401
V OUT
OUT 5
H DRIVE
OUT
Q502
R
D612
+
–
A
IC603
VOLTAGE
FEED BACK
2
3
IC504
AMP
B DRIVE
Q515,516
1
+16V SW
Q609
+16V SW
CONT
Q610
1 -V IN FLYBACK 3
+12V
#3 E220, E220E
11
D517
IC602
VOLTAGE
FEED BACK
T603 PIT
BOP CONT
Q510, Q513
FOCUS 32
BOP 3
BDRV 6
BIN 5
EWDRV 11
HFLB 1
VOUT2 12
VOUT1 13
HDRV
#3 E215E
-16V SW
Q617
-16V SW
CONT
Q616, Q618
TILT DRIVE
Q541, Q542
SYNC BUFF
Q538, 539
DF AMP
Q504, Q530
SWITCHING
Q501
H DRIVE
Q523,527
T503
T502
6
8
10
9
6
OVP
Q525, 534
+6.3V SW
Q607
+6.3V SW
CONT
Q608
D512
D511
1 IN
2
1
8
4
COMP
V AEF
FB
5
T504
H CENT
DRIVE
Q517,518
3
6
11
7
+5V SW
Q603
+5V SW
CONT
Q604
I SENSE
OUT
IC502
PWM CONT
OSC
H OUT
Q503
OUT 3
IC605
+5V REG
#3 E220, E220E
H CENT
Q519
BUFF
Q546
DF AMP
Q514, Q543, Q544
1
2
5
1
5
Q522
RY501
L505
RELAY DRIVE
Q540
+5V
+6.3V
-16V
+16V
+81V
+200V
D521
3
6
7
8
10
9
1
T501
FBT
ABL CONT
Q528, 529
5-4
OUT 3
IC607
+12V REG
1 IN
D509
SW
Q511
VR501
HV
ADJ
5
1
3
4
6
1
2
1
4
1
2
3
B-SS3562<NH.>-BD2-EPS05
µ-COM, DEFLECTION CONTROL,
DEFLECTION, HV, POWER SUPPLY
+12V
FV2 TO CRT
FV1 TO CRT
HV
TO CRT ANODE CAP
#3 E220, E220E
S CAP CHANGE
Q506, Q508
ABL CONT
Q533
4
15
13
FV2
FV1
14
11
12
HV
D
S CAP CHANGE
Q505,Q524,
Q536, Q537
1
2
3
4
5
6
CN603
CN305
ABL
+81V
+12V
+6.3V
+5V
CN505
ROTATION+
ROTATION-
CN504
1.2kV
CN502
CS1
CS2
CS3
CS0
H DY(-)
V DY(-)
V DY(+)
CN501
H DY(+)
H DY(+)
H DY(-)
C
TILT(ROTATION)
COIL
E
F
V.DY
H.DY
TO A BOARD
CN303
TO A BOARD
CN309
TO A BOARD
CN304
H
USER
CONTROL
DGC
N
L
1
2
3
G
CN601
AC-SOCKET
DGC
NC
DGC
CN602
3P
CN903
4P
1
2
3
4
MENU
ORANGE/LED
GREEN/LED
GND
1
2
3
4
P701
7P
MENU
ORG LED
GRN LED
GND
GND
+5V
ABL
+6.3V
+12V
GND
+81V
5-2. FRAME SCHEMATIC DIAGRAM
CN303
7P
CN603
7P
5-5
CN302
9P
CN901
10P
A
VIDEO,
RGB OUT
SOG
GND
H_RTN
V_RTN
G1
GND
CLAMP
SDA/I
SCL/I
1
2
3
4
5
6
7
8
9
D
CN301
6P
RGND
RED
GGND
GREEN
BGND
BLUE
µ-COM,DEFLECTION CONTROL,
DEFLECTION,HV,POWER
Auto-Size(NC) 10
9
SOG
8
GND
7
H_RTN
6
V_RTN
5
G1
4
GND
3
CLAMP
2
SDA/I
1
SCL/I
7
6
5
4
3
2
1
7
6
5
4
3
2
1
GND
+5V
ABL
+6.3V
+12V
GND
+81V
CN304
4P
CN502
4P
CS1
CS0
CS3
CS2
1
2
3
4
4
3
2
1
CS1
CS0
CS3
CS2
CN309
1P
CN504
1P
1.2kV
1
1
1.2kV
1
2
3
4
5
6
VIDEO CABLE
VIDEO CABLE
1
2
3
4
5
6
7
CN902
7P
DY+
DY+
DYDYDYDY+
ROTATIONROTATION+
CN505
2P
H
H
H
H
V
V
CN501
6P
B-SS3562<NH.>-KESSENZU-EPS05
H-IN
GND
V-IN
PCDET
SDA
SCL
PC+5V(NC)
2
1
1
2
3
4
5
6
H DY
TILT(ROTATION)
COIL
HV
V DY
HG
H
RGB G1 G2
PICTURE
TUBE
5-6
H
D
5-3. CIRCUIT BOARDS LOCATION
A
D board IC502, T501 (FBT)
D board D538, R521,
T501 (FBT)
D board IC901, R949,
T501 (FBT)
HV Regulator
Circuit Check
HV Hold-down
Circuit Check
Beam Current
Protector Circuit
Check
Part Replaced (])
• All resistors are in ohms.
• f : nonflammable resistor.
• F : fusible resistor.
f : internal component.
•
• p : panel designation, and adjustment for repair.
• All variable and adjustable resistors have characteristic curve B,
unless otherwise noted.
e : earth-ground.
•
•
E : earth-chassis.
• All voltages are in V.
• Readings are taken with a 10 M digital multimeter.
• Readings are taken with a color-bar signal input.
• Voltage variations may be noted due to normal production
tolerances.
•
* : Can not be measured.
• Circled numbers are waveform references.
• s : B + bus.
• S : B – bus.
• When replacing components identified by ] , make the
necessary adjustments indicated. (See page 3-1)
• When replacing the part in below table, be sure to perform the
related adjustment.
Pitch: 5 mm
Rating electrical power 1/4 W (CHIP : 1/10 W)
• All capacitors are in µF unless otherwise noted. (pF: µµF)
Capacitors without voltage indication are all 50 V.
• Indication of resistance, which does not have one for rating
electrical power, is as follows.
Note:
5-7
5-4. SCHEMATIC DIAGRAMS AND PRINTED
WIRING BOARDS
1
Circuit diagram division code
Ref. No.
Note: The components identified by shading and mark
0 are critical for safety. Replace only with part
number specified.
b
H
Board
l
Schematic diagram
Note: Les composants identifiés par un tramé et une
marque 0 sont critiques pour la sécurité. Ne les
remplacer que par une pièce portant le numéro
spécifié.
a
• Divided circuit diagram
One sheet of D board circuit diagram is divided into four
sheets, each having the code D-a to D-d . For example, the
destination ab1 on the D-a sheet is connected to ab1 on the
D-b sheet.
MENU
ORANGE/LED
GREEN/LED
GND
P701
4P
1
2
3
4
LED701
LT6463-23-D51
(POWER)
2
3
H (USER CONTROL)
USER CONTROL
TO D-a BOARD
CN901
(h)
D
C
B
A
1
(1) Schematic Diagram of H Board
R701
2.15k
1%
5-8
R706
3.83k
4
6
5
4
SW701
1
MENU
3
2
5
R709
17.4k
1%
R702
10.2k
1%
B-SS3562<NH.>-H..-EPS05
R705
6.19k
6
7
I
H
G
F
E
D
C
B
6
7
8
9
11
12
13
14
15
SIGNAL IN
HD15
PIG-TAIL
1
2
3
4
10
TO D-d BOARD
CN603
+81VS
GND
+12V
+6.3V
ABL
+5V
GND
CN303
7P
TO D-a BOARD
CN901
SOG
GND
H_RTN
V_RTN
G1
GND
CLAMP
SDA/I
SCL/I
CN302
9P
+5V
DDSCL
DDSDA
PCDET
CN306
4P
TO D-a BOARD
CN902
H-IN
GND
V-IN
PCDET
DDSDA
DDSCL
CN305
6P
H-IN
V-IN
GND
RGND
RED
GGND
GREEN
BGND
BLUE
R015
240
1/4W
R055
22k
R021
10k
C017
0.1
100V
D003
MTZJ5.1B
C027
470p
0
C020
47
16V
R028
1k
C048
220
16V
/WP
NC
VCLK
VCC
FB001
0.45µH
C019
0.1
100V
FB004 150µH
FB005 150µH
FB002
2µH
C011
10
100V
/TEST
VSS
SCL
IC005
24C21
DDC
+5V
C012
0.1
100V
C021
470
10V
+81VF
+80VF
C108
0.1
R102
4.7k
D012
1N4148
SDA
Q005
2SC945P
V SYNC
BUFF
5.0
+5V
D009
1N4148
C109
220p
FB009
C041
FB010 220p
D008
1N4148
R022
2.4k
R056
22k
C046
33p
C047
33p
C105
0.1
FB008
D013
1N4148
D011
1N4148
C026
2700p
50V
C120
0.1
R120
47
R106
47
R105
47
D010
1N4148
FB301
JW
FB201
JW
FB101
JW
H
0.75 Vp-p (H)
1
5-9
R302
L002
FB210
R008
2.4k
C022
390p
50V
1.08 Vp-p (H)
2
• A BOARD WAVEFORMS
1
2
3
4
5
6
7
1
2
3
4
5
6
7
8
9
1
2
3
4
1
2
3
4
5
6
1
2
3
4
5
6
7
8
9
R026
470
R046
3k
C302
10 50V
R013
4.7k
R029
1.5k
C035
100
10V
+5V
D301
1SS119
D302
1SS119
+5V
C029
1000p
50V
C004
0.22
16V
C303
0.1
50V
5.0
VSS
P1/R
3.10 Vp-p (H)
P7
C023
100
10V
P0/BK0
P2
TCK
VDD1
P3/G
SIN
P5/B
CS
P4
HOR
SCK
VERT
VIR
AC
IC003
M35047
OSD
VDD2
P6
R054
1M
+5V
CPOUT
C103
0.1
50V
5.0
5.0
5.0
1.3
4
C032
1 50V
C033
4700p 50V
R012
1k
R016
470
+5V +12V
C203
0.1
50V
+12V
C002
220
16V
+12V
D201
1SS119
EXTFB
GNDA
GOUT
VCCR
OSDR
GNDR
MBRI
BOUT
EXTFB
BLK
SOGI
VCCG
OSDG
GNDG
0
R002 100
R001 100
R036 100
R037 100
R030
10k
0.2
5.0
5.0
2.9
2.9
1.5
2.1
0.6
4.7
2.1
1.1
4.4
2.9
2.0
C043
4.7
35V
N.P
R004
100
L001
100µH
3.24 Vp-p (H)
R113
33
0
R213
33
0
C030
470
10V
R313
33
5
JW035
150µH
+5VF
CLAMP
SOG OUT
ABLIN
SCL
DA4
GND5
GNDB
SDA
DA3
OSDB
VCC
DA2
VCCB
NC
DA1
BIN
3
EXTFB
GIN
2
ROUT
VCC2
RIN
1
OSD BLKIN
IC001
M52743BSP
PRE AMP,OSD MIX
0
3.8
5.0
0.6
4.4
0.1
2.6
0.1
2.9
0.1
2.6
0.1
C054
0.1
R003
18k
R308
20k
R208
20k
R108
20k
L301
0.1µH
L201
0.1µH
C010
0.1
50V
FB006
3µH
C009
47
16V
FB218
7
GND
+12V
C038
47
16V
D001
1SS119
R309
470
3
FB215
R215
150
1/2W
C207
0.1
R025
2.2k
D305
HSS82
R311
1M
D304
HSS82
C306
0.1
100V
R209
470
1
D103
HSS82
C107
0.1
C037
0.22
16V
R032
1K
C028
330p
C014
1000p 2kV
SG001
C106
0.1
100V
R033
220k
C015
0.47
16V
R023
470k
+12V
C016
1000p
D105
HSS82
R111
1M
D104
HSS82
D017
ER106
C045
10000P
1.5KV
R042
100
1/2W
C013
0.1
50V
+6.3V
FB003
2.2
2W
44.5 Vp-p (H)
8
R024
150k
R031
22M
D205
HSS82
R211
1M
D204
HSS82
C206
0.1
100V
R109
470
Q101
BF420
R CUT-OFF
+81V
Q004
2SC4634
G2 CONT
FB315
R315
100
1/2W
L102
0.47µH
52.7
2
FB115
R107
4.7k
Q201
BF420
G CUT-OFF
D203
HSS82
L202
0.47µH
10
R115
100
1/2W
R VOUT2
41.9
4
GND2
C012
0.1
100V
+81V
R207
4.7k
Q301
BF420
B CUT-OFF
D303
HSS82
5
53.1
6
VCC
C011
10
100V
C307
0.1
C019
0.1
100V
+80VF
L302
0.47µH
C310
100p
G VIN3
8
G VOUT3
43.5 Vp-p (H)
7
R307
4.7k
C210
100p
R310
3k
+81V
C110
100p
R110
3k
R210
3k
9
R VIN2
2.9 2.0
10
11
2.1
+12VF
IC002
LM2415
RGB OUT
3.02 Vp-p (H)
6
D005
1SS119
C050
3900p
100V
R303
1k
R304
12
R203
1k
R204
12
L101
0.1µH
C304 C204 C104
0.1
0.1
0.1
50V
50V
50V
C008
0.1
50V
R005
1k
R006
10k
+12V
R103
1k
R104
12
C005 C006
220
0.1
16V
50V
+12VF
9
B VIN1
8
VBB
+12V
D101
1N4148
D202
1SS119
7
GND1
6
D102
1N4148
C034 R039
0.1 2.4k
50V
R020
18k
C025
0.1
50V
Q002
2N3904
CLAMP AMP
D002
1N4148
H
C102
10 50V
C202
10 50V
0.75 Vp-p (H)
3
+5V
+80VF
+81VF
+12V
+12V
+6.3V
0.2
0.8
R010
100
R011
470
R014
4.7k
Q003
2N3904
H SYNC BUFF
0
4.4
+5V
D004
1SS119
R018
100
R019
100
Q001
2N3904
CLAMP AMP
-0.2
R007
100
1.1
R009
1k
+5V
R301 R201 R101
75
75
75
5
B VOUT1
4
A(VIDEO,RGB OUT)
6
CN301
9P
5
7
8
3
4
3
5
2
17
18
2
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
A
1
1
2
20
19
18
17
3
4
5
6
7
8
9
10
R112
300
1/2W
6
5
4
OUT.B -IN.A
Vcc
OUT,A
Vee
R034
10k
1/2W
5-10
R035
2.2M
1/2W
1
2
3
4
1
CN309
1P
1.2kV
13
43.5 Vp-p (H)
qa
TO D-b BOARD
CN502
CS1
CS0
CS3
CS2
CN304
4P
TO D-b BOARD
CN504
43.5 Vp-p (H)
0
B-SS3562<NH.>-A..-EPS05
HV
TO
D BOARD FBT
-IN.B +IN.A
+IN.B
IC004
LM358
AMP
SG301
SG201
SG101
12
V901
PICTURE
TUBE
43.5 Vp-p (H)
9
J001
CRT_SOKET
RGB G1 G2
C039
100
16V
+12V
R312
300
1/2W
R212
300
1/2W
HG
H
11
6
(2) Schematic Diagram of A Board
7
8
16
15
14
13
12
11
5
4
3
2
1
44.5 Vp-p (H)
qs
14
I
H
G
F
E
D
C
B
1
2
3
4
5
6
7
1
2
3
4
TO A BOARD
CN302
R919
*
C915
*
C926
100p
R952 47
R945 47
D902
MTZJ-5.1A
R958
100
MENU
ORANGE/LED
GREEN/LED
ac1
ad1
C927
100p
0.5
R920
*
R959
*
HSYNC/O
RESET
Q902
*
H SYNC BUFF
C909
470p
R951
28k
SW901
C924
4.7
R915
30.1k
R948
1.4k
C905 2.2
R950
47k
R949
10k
+5V
R921
1k
VSYNC/O
MENU
ABL/O
H-DRIVER
C904 2.2
C903 2.2
C902 2.2
C906
2.2
D910
1N4148
D911
1N4148
R914
33.2
R911 1k
R909 1k
R908 10k
R943
100
FB901
2µH
C910
0.1
R912 10k 1/8W
C908
0.1
+5V
R906 1k
R905 1k
R904 100
R903 1k
R902 1k
TILT
TEST
0.4
0
4.2
0.5
C907
10
4.9
C925
0.1
C928
0.1
3.1
R907
1k
2.5
1.2
4.9
a
b
1
D-b sheet.
Circuit diagram division code
Ref. No.
5-13
• Divided circuit diagram
One sheet of D board circuit diagram is divided into four
sheets, each having the code D-a to D-d . For example, the
destination ab1 on the D-a sheet is connected to ab1 on the
1
SCL/I
2
SDA/I
3
CLAMP
4
GND
5
G1
6
V_RTN
7
H_RTN
8
GND
9
SOG
Auto-Size(NC) 10
CN901
10P
TO VIDEO CABLE
H-IN
GND
V-IN
PCDET
SDA
SCL
PC+5V(NC)
CN902
7P
TO H BOARD
P701
MENU
ORANGE/LED
GREEN/LED
GND
CN903
4P
D-a
3
(µ-COM,DEFLECTION CONTROL)
H-CENTER/O
BRI
ABL/PWM
A
2
0.5
PA3
PA4
PS5/PWM5
PS6/PWM6
PA6
OSCIN
PB7/AIN3/
PWM1
PB6/AIN2/
PWM0
PB0/SCLD
PD4/ITB
PD3/ITA/
VFBACK
PD2/
CSYNCI
VSYNCI
PD1/
HSYNCO
4
PD5/HFBACK
3
PD0/
VSYNCO
HSYNCI
PD6/CLAMPOUT
USBDP
VSS
PB2/SCU
PB1/SDAD
PB3/SDAI
VDD
USBDM
PA7/
BLANKOUT
PB4/AIN0
USBVCC
OSCOUT
PB5/AIN1
5
PA5
PC7/PWM7
2
PA2/TDO
PA1/RDI
1
PC3/PWM3
PC4/PWM4
Reset
TEST/Vpp
PC2/PWM2
PA0/OCMP
PC1/VA
IC901
ST72774
CPU
PC0/
HSYNCDIV
4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
1
GREEN/LED
0.7 ORANGE/LED
R925
10k
-0.6
D905
MTZJ-5.1A
R913
1k
R937 47
X901
24MHz
R954
10k
IC903
M51951B
RESET
+5V
2
GND
D903
MTZJ-5.1A
R930
10k
1/8W
R931
10k
1/8W
+5V
D904
MTZJ-5.1A
R928 R929
10k 10k
1/8W
D907
1N4148
D908
1SS119
H_RETURN
R927
2.7k
1/8W
+5V
R953
10k
3 OUT IN 1
R935
10k
5.0
C921
22p 50V
C922
22p 50V
C923
2.2
R940
10k
+5V
6
C919
47p
TEST
BLK
C918
47p
1
3.2 Vp-p (H)
2
3.4 Vp-p (H)
4.9
5.0
4.9
C570
10
50V
R5122
60.4k
7
R5123
10k
A2
SCL
SDA
3
1
C920
0.1
4
8
C563
330
16V
8
C502
0.1
3.2
4.9
5.0
0.2
C503
0.1
R505
2.8k
1%
D542
1N4148
C507
0.0047
100V
5.4
4.5
R504
732 1.0
1%
C506
0.01 2.6
100V
2.4
R503 4.7k
C504 0.01 100V
2.7
R502
22.1k 1% 3.1
D541
1N4148
C505
0.1
C516
33p
50V
7
IC504(2/2)
LM358N
6
5
4.0 Vp-p (V)
4
-16V
C587 C580
0.1 0.1
-1.4
+12V
Q542
2SB647
TILT DRIVE
-2.0
R5124
100
-2.0
Q541
H2N6718L
TILT DRIVE
5.0 Vp-p (H)
R933
22
R932
22
Vss
A1
TEST
A0
R5120
26.7k
C572
47
16V
Vcc
IC902
M24C16BN6
EEPROM
C571
0.1
50V
0.3
3
IC504(1/2)
LM358N 0.3
AMP
2
R934
47
+5V
R5121
10K
• D - a BOARD WAVEFORMS
D906
MTZJ-5.1A
R926
100
R946
100
1/8W
R936
1M
R956
160
CS4
0.2
1.7
5.0
4.1
0.7-4.0
5.0
4.9
0.1
2.3
2.2
0.1
4.9
4.9
0
R941
220
1/8W
2.0
5.0
R942
220
1/8W
5
8
7
6
5
22
TILT
1
2
(3) Schematic Diagrams of D (a
a , b , c , d ) Board
XSEL
HDRV
VCAP
GNDS
HREF
FOCUS
2.8
R501
27k
0.2
6.1
2.5
1.5
2.5
5.3
R507
10k
R592
47k
0.1
5
R506 C508
10k 100p
50V
C531
0.01 R596
100V 59k
R500
43
R513
100
R571
4.7k
6
D501
1SS119
C509
3300p
100V
R508
12k
R522
*
+12V
HSYNC/O
FOCUS
HFLB
BOP
BDRV
HDRV
ab4
ab3
ab2
ab1
ad3
ad2
11
1
2
7
4.7k
4.7k
10k
-
2N3904
100p
E220 [NH]
8
13
9
4.7k
4.7k
10k
-
2N3904
100p
E220 [SH, EQ]
3.0 Vp-p (V)
TILT(ROTATION)
COIL
R522
R919
R920
R959
- :Not used
Q902
ROTATION+
ROTATION-
5-14
12
D-a BOARD * MARKS LIST
C915
Ref. No.
CN505 2P
#3
5.0 Vp-p (V)
B-SS3563<AEP>-D..-P1-EPS05
HUNLOCK
G1/VBLK
C512 C513
100p 100p
50V
50V
R510 R511
100 100
5.0 Vp-p (H)
R404 R406
0.75 1.5
1W
R407
330
1W
C404
1000
25V
C405
0.22
50V
+16V
10
R403
3.3 1/2W
L509
150µH
R411 R412
6.81k 6.81k
1%
1%
C402
470
25V
C403
0.022
100V
R401
1.82k
3
C510 C534 C535
1000 0.1 100
16V 50V 16V
-16V
4
6
-14.3
C408
470
35V
D402
1N4002
2.8 Vp-p (24MHz)
5
HFLB
HSMOD
6.3
BOP
XRAY
HPLL2
BSENS
BDRV
BIN
HBUF
HCAP
PGND
HPLL1
10
VCC
2.9
2.9
0
5.7
EWDRV
VOUT2
VOUT1
VREF
9
8
7
VSYNC
HSYNC
VAGC
VSOMD
COR
SDA
6
0.4
0.8
SCL
2
15.2
IC401
LA78040
V OUT
R529
1k
HUNLOCK CLBL
IC501
TDA4841
DEFLECTION
CONTROL
0.1
0.8
Q526
2SC3400
BUFF
C409
1000p
100V
7 +
0.7
1 -
0.7
9
R402
C406
1.82k 0.0033
1%
100V
31
32
3
4
17
18
19
20
21
22
23
24
25
26
27
28
29
30
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
VSYNC/O
2.0 Vp-p (V)
4.7k
4.7k
10k
-
2N3904
100p
E220E
12.0 Vp-p (H)
0
470
JW
0
-
-
E215E
14
Ò D
-a board
Schematic diagram
I
H
G
F
E
D
C
B
V DY-
V DY+
HUNLOCK
BOP
BDRV
HDRV
HFLB
FOCUS
G1/VBLK
D535
1SS119
D539
1SS119
R526
4.7k
R533
1.3k
2W
JW108
*
C515
0.022
250V
157.5
Q512
2SC3400
BOP CONT
6.1
R568
10k
2.9
D518
1SS119
R567
10k
C542
R580 0.022
100V
*
D510
1SS119
5.3
+12V
Q520
*
H DRIVE
16.4
3.1
D506
1SS119
Q513
2SA733
BOP CONT
a
b
1
Ref. No.
Circuit diagram division code
58.9
L503
10mH
Q511
H2N6718L
SW
R517
10k
R560
150k
R527
10k
4.2
5-15
R587
JW
57.8
Q523
2SD669A
H DRIVE
BRI
S
C541
4.7
D517
1SS119
C576
0.1
R5103
20k
-27.6
R583
1.8 3W
R530
1.8 3W
92.8
SG501
1.5KV
R532
47
1/2W
Q503
2SC5587
H OUT
D507
SB140 -0.4
R5102
13k
1.4
1.9
Q531
KSP92
5
D508
5TUZ47C
R5113
51k
5
7
2
11
FB508
2.3µH
C521
4300p
2kV
R576
150k
1/2W
0.4
L501
1.2mH
R597
33
1/2W
C565
2.2
250V
R565
1k
D512
PS104R
C550
0.01
250V
D511
PS104R
R5134
4.7
1W
58.0 Vp-p (V)
qa
qs
0.6
D
1.2
R575
3k
-b board
Q504
2SC945
DF AMP
R5130
10k
R5129
1k
95.7
102.9
D525
MTZJ-5.1A
Q505
2SC945
S-CAP
CHANGE
R538
4.7k
0.6
0
R539
10k
+12V
Q518
2SB649A
H CENT DRIVE
-77.3
96.2
Q517
2SD669A
H CENT DRIVE
C592
4.7
35V
D592
1SS119
+12V
7
1k Vp-p (H)
C560
4700p
44.6
qd
R544
100k
1/2W
S
Q524
IRF640
S-CAP CHANGE
C524
*
Q519
2SC2688
H CENT
95.6
C549 R535
330
1k
25V
C548 R536
330 6.8k
25V
ABL/PWM
R572
10
R573
36k
+12V
1.0
l
Schematic diagram
1.8 Vp-p (V)
R5108
18k
R5107
10k
C595
0.1
400V
C593
0.22
63V
R577
360
74.8
R5109
1M
Q529
2SC945P
ABL CONT
Q530
2SC2688
DF AMP
C589
1
R5110
470
R5111
20k
R5131 C585
820k 330p
1/8W 500V
FB507
2.3µH
C583
22
160V
T504
R5112
6.8k
Q528
2SC945P
ABL CONT
+12V
6
• D - b BOARD WAVEFORMS
6
7
4
5
8
C538
0.1
R528
120
1/2W
C543
1000p
100V
9
3
10
2
1
6
7
2
1
8
3
10
9
T502
T503
C574
330
D523
1SS119
4
5
R585
10k
R523
10k
16.4
15.8
Q532
16.4 2SA733
C523
47
35V
Q510
2SA733
BOP CONT
16
Q502
*
H DRIVE OUT
R518
510k
56.4
Q527
2SC945
H DRIVE
D504
1SS119
2.5
R582
2.7k
R512
1k
1/8W
4
D527
HZ12A1
Q535
2SC3400
R531
*
+16V
0.5
C555
0.1
50V
3.3
R563
47k
D540
1SS119
C575
0.01
R509
3.6k
C514
0.1
D503
D2L40
C518
1500p
1kV
C517
220p
3kV
Q516
2SA733
B DRIVE
5.4
FB501
3µH
Q515
2SC945
B DRIVE
D502
MTZJ-15A
S
C587
33
16V
R525
56
92.7
C401
0.1
250V
Q501
SFS9634
SWITCHING
Q521
*
H DRIVE
15
6.0
+12V
R540 C556
1M 100
1/2W 250V
FB504
3µH R524
8.2k
+200V
D519
PS104R
(SR1003)
+5V
Q401
2SC945
SW
R409
10k
R408
3.3k
1/2W
R516
4.3k
• Divided circuit diagram
One sheet of D board circuit diagram is divided into four
sheets, each having the code D-a to D-d . For example, the
destination ab1 on the D-a sheet is connected to ab1 on the
D-b sheet.
ab4
bc2
bc1
ab3
ab2
ab1
(DEFLECTION)
D-b
3
BLK
2
H-DRIVER
A
1
C547
0.1
50V
H-CENTER/O
C594 C584
*
*
C557
4700p
43.9
R5119
4.7k
R534
10
1W
R578
1k
1/2W
S
C528
*
L506
10mH
R547
*
Q508
*
S-CAP
CHANGE
R549
*
+12V
5
4
3
L504
*
RY501
R557
10
1W
2
1
R591
56k
C573
4.7
35V
C582
220
100V
+81V
R589
10k
12.0 Vp-p (H)
qg
R545
*
9
D532
Z10-160B
Q506
*
S-CAP CHANGE
C526
*
D526
1SS119
Q537
2SC945
S-CAP
CHANGE
0.6
0
R5118
10k
+12V
R595
4.7k
Q540
2SC945
RELAY DRIVE
R5117
JW(10)
D534
JW
R574
82k
+12V
L502
100µH
D524
1SS119
D530
1SS119
C591
0.1
R590
1M
D531
1SS119
R5126
1.18k
+12V
Q514
2SC945
DF AMP
Q544
TIP127
DF AMP
R5104
10k
1/2W
62.0 Vp-p (H)
qf
R5115
100k
1/2W
S
R5106
470
R5006
15k
D513
BYV26C
Q543
TIP122
DF AMP
Q536
IRF640
S-CAP CHANGE
C525
*
C568
*
R5128
30
1/2W
R5127
10
1/2W
D520
PG104R
R5004
0.12
1/2W
C590
0.1
Q533
2SA733
R586
80.7k
8
C566
1
250V
qh
C522
*
C577
22
250V
Q546
*
BUFF
D514
PG104R
R543
270
1W
R5008
0.12
1/2W
R598
*
L505
120 Vp-p (H)
D522
PG104R
10
14 13
12
11
1
2
3
4
6
5
4
3
2
1
5-16
B-SS3563<AEP>-D..-P2-EPS05
CS4
bc6
bc5
bc4
bd1
bc3
V DY+
V DY-
11
H.DY
R531
R545
R547
R549
R580
R598
- :Not used
Q502
Q506
Q508
Q520
Q521
Q546
L504
V.DY
1.8k
100k/ 1/2W
4.7k
10k
100
1k
IRFU110
IRF640
2SCS945P
2SCS945P
2SA733
RN1203
28➩H
-
C522
C524
C525
C526
C528
C568
C584
C594
JW108
E220 [NH]
0.24/ 250V
0.12/ 250V
0.1/ 250V
0.33/ 250V
4700p
1000p
470p
470p
Ref. No.
D-b BOARD * MARKS LIST
TO A BOARD
CN304
CS2
CS3
CS0
CS1
CN502
4P
V DY+
V DYH DYH DYH DY+
H DY+
CN501
6P
#3
12
1.8k
100k/ 1/2W
4.7k
10k
100
1k
IRFU110
IRF640
2SCS945P
2SCS945P
2SA733
RN1203
28➩H
-
0.24/ 250V
0.12/ 250V
0.1/ 250V
0.33/ 250V
4700p
1000p
470p
470p
E220 [SH, EQ]
13
E220E
1.8k
100k/ 1/2W
4.7k
10k
100
1k
IRFU110
IRF640
2SCS945P
2SCS945P
2SA733
RN1203
28➩H
-
0.24/ 250V
0.12/ 250V
0.1/ 250V
0.33/ 250V
4700p
1000p
470p
470p
E215E
1k
470
-
2SC2655-Y
-
25.5➩H
JW
0.33/ 250V
0.18/ 250V
0.24/ 250V
680p
680p
I
H
G
F
E
D
C
B
A
1
D529
1N4148
R584
47k
C558
0.033
100V
3
C554
470p
C561
680p
C559
0.0022
100V
OSC
GND
VCC
OUT
ISENSE
VAEF
FB
COMP
IC502
UC3843A
PWM CONT
a
b
1
D-b sheet.
Ref. No.
Circuit diagram division code
5-17
C562
0.1
R569
680
1/2W
D533
1SS119
R5133
10k
Q539
2SC945
SYNC BUFF
R593
JW
+12V
4
• Divided circuit diagram
One sheet of D board circuit diagram is divided into four
sheets, each having the code D-a to D-d . For example, the
destination ab1 on the D-a sheet is connected to ab1 on the
ac1
bc1
bc2
D-c (HV)
2
1
2
3
4
8
7
6
5
C546
100p
C598
0.1
Q538
2SC945
SYNC BUFF
C553
470p
R579
2.7k
R570
2.2k
R561
47k
5
Q534
2SC945
OVP
R553
100k
R556
10k
R558
15k
R559
1k
C564
47
25V
R555
100
D516
1N4148
R5132
47k
C539
10
100V
+81V
C545
10
Q525
2SA733
OVP
D537
1N4148
R554
15
1/8W
6
C540
0.1
R5003
10k
R552
100k
D538
MTZJ-15A
R520
0.22
1W
S
Q522
2SK2843
R5001
100 2W
C537
3900p
1kV
R599
1.82k
R551
10k
R521
23.7k
D515
BYV26C
D521
BYV27-200
FB502
10.8µH
R519
100 2W
7
D509
PS104R
C599
220
C536
1500p
1.2kV
8
3
6
7
8
10
9
1
9
T501
FBT
HV
4
15
16
13
FV2
FV1
14
12
11
R5009
0.12
R594
20k
C533
2.2
HV ADJ
VR501
100k
R515
68k
D528
RGP02-18
TO
PICTURE TUBE
10
D543
RGP02-18
R5100
100k
bc6
bc3
bc4
bc5
1
12
5-18
B-SS3563<AEP>-D..-P3-EPS05
C567
0.01
2kV
C532
0.047
100V
11
CN504
1P
1.2kV
TO A BOARD
CN309
13
14
Ò D
-c board
Schematic diagram
I
H
G
F
E
D
C
B
N
L
1
2
3
18.7
220
1/8W
K
A
0.1
G
1
D-d
R623
100
D608
RD27EB4
C614
0.1
50V
C603
470p
250V
R626
15k
0.1
SW
C615
100
16V
Q601
2SA733
10k
2.6
R625
C604
470p
250V
C648
D609
1SS119
2.1
R624
9.1k
4700p
400V
VA601
C601
0.68
R627
10k
+16V
R628
62 L609
1/4W 100µH
F601
4A
250V
Q615
2SC945P
RELAY DRIVE
D611
1N4148
5
6
2
RY601
3
R621
220
1/8W
TH602
16.5
4
FB613
300µH
FB612
300µH
(POWER SUPPLY)
0.1
IC606
MCR100
R622
C619
0.1
50V
R629
160
1/4W
C640
0.1
250V
R673
47k
C649
4700p
400V
250V
a
b
1
Circuit diagram division code
Ref. No.
5-19
• Divided circuit diagram
One sheet of D board circuit diagram is divided into four
sheets, each having the code D-a to D-d . For example, the
destination ab1 on the D-a sheet is connected to ab1 on the
D-b sheet.
DGC
DGC
NC
DGC
CN602
3P
G
CN601
AC-SOCKET
ad1
4
C643
0.1
50V
0.7
R677
1M
D629
1SS119
R619
10k
D610
1SS119
2
1
R618
10k
R672
2M
Q611
2SC3400
SW
3
4
LF601
S601
1.1
0.4
2.5
3.4
G
D630
1SS119
5.7
51.9
IC601
UC3842A
PWM CONTROL
K
A
OSC
C654
22
25V
Vcc
FB
ISENSE OUT
GND
VAEF
COMP
C613
270p
50V
R612
4.99k
1%
C612
0.01
100V
7.1
5.0
R603
30k
2W
TH601
10
D601
D4SB60L-F
AC RECT
IC604
MCR100-8
POWER
R601 C602
1M 0.47
1/2W 250V
5
2
3
1
3
4
2
8
7
6
5
A
1
C605
4700p
250V
D621
*
R609
2.7k
1/4W
D606
1N4148
C650
*
L606
*
R678
1.2M
R605
150k 2W
C611 R616
680p 3.92k
50V
D
-d board
l
3
1
4
6
VA603
FB614
1.5µH
T601
*
0.1
R614
0.22
2W
R615
1.82k
R670
1M
7.0
C620
100p
1kV
S
Q602
2SK2607
SWITCHING
124.4
R653
220
2W
D605
FB621
UF4007G23 JW
D626
1N4148
FB611
*
C606
330
450V
C608
0.1 400V
D623
*
D607
RD27EB4
FB616
2µH
C607
220
35V
C609
*
JW105
*
D627
*
FB609
*
7
Schematic diagram
R611
18
R610
10
6
5.0
4
3
C616 R620
0.1
1k
50V
1.7
9
8
2
1
10
11
12
7
C647
100 35V
13
6
D604
PS104R
14
15
5
4
16
17
2
3
18
1
IC602
TLP621Y
VOLTAGE
FEED BACK
T603
FB620
3µH
JW105
*
FB610
*
8
5.3
+5V
FB608
2µH
FB622
3µH
FB607
JW(10)
FB606
3µH
D616
UF5402G
D617
PG104R
A
K
R640
1k
2.5
C623
100p
C630
470
25V
R641
470
C622
0.22
C655
10
160V
R644
2.8k
1%
R675
107k
1%
R643
115k
1%
C652
0.22
250V
C626
100
250V
D612
1N4004
C625
220
100V
C628
1000
25V
R660
10k
L605
100µH
C632
470
25V
C651 C645
1000 470
25V 16V
L601
100µH
D622
UF5402G
IC603
TL431ACLP
VOLTAGE
FEED BACK
R
5.3
D628
ER206
10
D618
SR10031A
D631
D615
UF5404G UF5404G
C638
R648
1000p 1kV
150 1/2W
D613
ER206
R654
0.12 1/2W
R642
160
1/4W
9
L610
JW
R651
10k
D619
1SS119
Q616
2SC3400
-16V
SW CONT
Q618
2SA733
-16V
SW CONT
1
2
IN OUT
GND
R659
470
1
3
2
IN OUT
GND
3
4.9
+12V
R634
10k
Q604
2SC3400
+5V SW CONT
+5V
+6.3V
12
bd1
ad3
ad2
1
2
3
4
5
6
7
5-20
#3
TO A BOARD
CN303
+81V
GND
+12V
+6.3V
ABL
+5V
GND
CN603
7P
13
BYV26C
UF5406
UF5406
3➩H
3➩H
3➩H
1.5➩H
15➩H
PFC TRANSFORMER
C609
C650
D621
D623
D627
FB609
FB610
FB611
FB614
JW105
JW106
L606
T601
- :Not used
E220 [NH]
0.33/ 630V
0.022/ 630V
Ref. No.
D-d BOARD * MARKS LIST
B-SS3563<AEP>-D..-P4-EPS05
C635
1000
10V
R658
10k
C658
R633
1k
Q603
2SA966
+5V SW
C634
1000
16V
+5V
L607
100µH
IC607
MCT7812CT
+12V REG
IC605
MCT7805CT
+5V REG
C646
1000
25V
+81V
L604 +200V
100µH
L603
100µH
R656
10k
4.9
+16V
R666
1.5k 1/4W
0.1
D603
1N4148
Q610
2SC3400
+16V SW CONT
R665
10k
15.9
L602
100µH
L608
JW
Q608
2SC3400
+6.3V SW CONT
2.6
Q609
2SB1375
+16V SW
-16V
R669
1 1/2W
R652
300
5.9
Q607
2SA966
+6.3V SW
D625
1SS119
11
Q617
2SC2655Y
-16V SW
R630
2.2 2W
C633
1000
25V
R661
1.5k
-
JW
JW
JW
JW
JW
JW
-
-
E220 [SH, EQ]
PFC TRANSFORMER
15➩H
-
3➩H
3➩H
3➩H
1.5➩H
BYV26C
UF5406
UF5406
0.33/ 630V
0.022/ 630V
E220E
14
E215E
PFC TRANSFORMER
15➩H
-
3➩H
3➩H
3➩H
1.5➩H
BYV26C
UF5406
UF5406
0.22/ 630V
0.01/ 630V
5-5. SEMICONDUCTORS
BH3863F
BH3863F-E2
M52743BSP
n
RN1203
2SC4632LS-CB7
MAA3371X
LETTER SIDE
n
1
TOP VIEW
36 pin DIP
ST72774
1
TOP VIEW
24 pin SOP
B
n
C
1
LA78040
TOP VIEW
42 pin DIP
TDA4841
BYV26C
UF05G
MCR100
MCR100-8RL
CATHODE
n
1
TOP VIEW
1
CATHODE
CATHODE
GATE
BF420
LM2415T
2N3904
DTC124ESA
2SC3400
E B
C
2SA1221-L
n
E
E C
B
C
B
TOP VIEW
8 pin DIP
MCT7812CT
TA7805S
2SA733-Q
2SA733TP-QP
2SA966-Y
2SB647A-C
2SC2655
2SC2655-Y
2SC945-P
IRFU110
IRFU110A
ANODE
ANODE
E C
B
1
D2L40-TA
ER106
HSS82
HZ12
HZ18-2
HZ5C1
HZ5C2
MTZJ-T-73-15A
PS104R
RD27EB4
RGP02-18
SB140-6339
UF4007G23
UF5402G
UF5404G
UF5406
10E2
IN4002
IN4004
IN4148
CATHODE
IRF640
2SB649-C
2SB649A-B
2SC2688-LK
2SD669AVC
TOP VIEW
20 pin DIP
M51951BSL
G
D
LETTER SIDE
S
-
-
E C
B
n
~
~-
-
M35047
~
~
-
EGP10D
CATHODE
E
C B
5-23
ANODE
CATHODE
TLP621D4-Y-LF2
4
3
1
2
2
D4SB60L
D4SB60L-F
S
SEL4225R-D
4
3
ANODE
D
ANODE
1
G
1
MTZJ-15A
MTZJ-5.1A
MTZJ-5.1B
RD15ES-B1
RD5.1ESB2
1SS119-25
1SS119-25TD
32 pin DIP
7
LM358N
M24C16BN6
UC3842A
C3843A
24LC21/P
CATHODE
ANODE
E
E C
B
ANODE
CPD-E220/E220E/E215E
SECTION 6
EXPLODED VIEWS
NOTE:
• Items with no part number and no
description are not stocked because they
are seldom required for routine service.
• The construction parts of an assembled
part are indicated with a collation number
in the remark column.
• Items marked " * " are not stocked since
they are seldom required for routine
service. Some delay should be anticipated
when ordering these items.
Les composants identifiés par une
marque ¡ sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
6-1. CHASSIS
7-685-648-79
7-685-872-09
7-685-663-71
7-685-881-09
+BVTP 3X12
+BVTT 3X8
+BVTP 4X16
+BVTT 4X8
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
8418113010
8026114012
4
5
10
3
1
7
9
6
REF.NO. PART NO.
1
#1 1
3
4
#1 4
DESCRIPTION
REMARK
REF.NO. PART NO.
* A-1272-229-A A BOARD, COMPLETE [E220, E220E]
S07C2U0242
* A-1272-279-A A BOARD, COMPLETE [E215E]
SOE2150244
* 4-060-151-01 STOPPER, CABLE
4-072-384-01 CABINET [E220E, E215E]
4-072-384-11 CABINET [E220]
6
#1 6
#1 6
#1 6
7
5
#1 5
#1 5
* 4-079-241-01 LABEL, INFORMATION [E220E]
9011097C2V
* 4-079-241-11 LABEL, INFORMATION [E220]
9011097C1N
* 4-079-241-21 LABEL, INFORMATION [E215E]
6-1
9
10
DESCRIPTION
REMARK
* A-1348-021-A D BOARD, COMPLETE [E220E]
C07C2U0144
* A-1348-026-A D BOARD, COMPLETE [E220 for NH]
SM7C1J5144
* A-1348-036-A D BOARD, COMPLETE [E220 for EQ, SH]
* A-1348-037-A D BOARD, COMPLETE [E215E]
SOE2155144
0 1-453-358-11 TRANSFORMER, FLYBACK 7050307C2U
1-757-540-11 I/O CABLE ASSY
4-073-622-01 SPONGE
C7107C2U11
CPD-E220/E220E/E215E
6-2. PICTURE TUBE
7-685-663-71
7-685-881-09
+BVTP 4X16
+BVTT 4X8
8026114012
68
64
62
61
66
65
60
64
69
59
58
70
63
57
71
72
61
55
51
56
67
54
52
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
53
Les composants identifiés par une
marque ¡ sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
REF.NO. PART NO.
51
DESCRIPTION
X-4038-291-1 BEZEL ASSY [E220E]
#1 51
X-4038-292-1 BEZEL ASSY [E220]
#1 51
X-4038-570-1 BEZEL ASSY [E215E]
52
53
REMARK
REF.NO. PART NO.
52-54
GP7C2V7001
52-54
1Q010T7C1N
52-54
IR011TE215
4-072-387-01 BUTTON, POWER
3-653-339-01 SPRING, COMPRESSION
54
55
56
4-042-353-11 EMBLEM (NO.7), SONY
* A-1304-219-A H BOARD, COMPLETE
S07C2U0342
4-384-096-01 SCREW (4X16), TAPPING, +P
8433144020
#1 57 0 8-738-549-05 PICTURE TUBE (17TKB)
(FILM INTENSITY SOUTH) [E220 for EQ, SH]
57 0 8-738-558-05 PICTURE TUBE (17TKB)
(FILM INTENSITY UP) [E220 for NH, E220E, E215E]
6-2
DESCRIPTION
REMARK
58 0 8-451-435-12 DEFLECTION YOKE (Y17TKJ-M)
59 0 1-452-923-41 NECK ASSY
60
4-060-166-01 SPACER, DEFRECTION YOKE
61
4-045-123-21 HOLDER, DEGAUS COIL
62
4-060-155-01 HOLDER, HV CABLE
63
4-060-603-01 SPRING, TENSION
64
4-072-413-01 BAND, DG COIL
65 0 1-419-255-11 DEGAUSS COIL
66
4-365-808-01 SCREW (5), TAPPING
67
X-4037-104-1 STAND ASSY
68
69
70
71
72
4-072-411-01
4-308-870-00
1-452-032-00
1-452-094-00
4-051-736-21
HOLDER, DGC
CLIP, LEAD WIRE
MAGNET, DISK; 10mmφ
MAGNET, ROTATABLE DISK; 15mmφ
PIECE A (90), CONV. CORRECT
56
CPD-E220/E220E/E215E
6-3. PACKING MATERIALS
101 102
103
104
105
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
Les composants identifiés par une
marque ¡ sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
REF.NO. PART NO.
DESCRIPTION
REMARK
REF.NO. PART NO.
#1 101 0 1-776-027-11 CORD SET, POWER [E220E, E215E]
102
4-079-242-11 MANUAL, INSTRUCTION [E220E]
9012097C2V
#1 102
4-079-242-21 MANUAL, INSTRUCTION [E220]
9012097C1N
#1 102
4-080-479-11 MANUAL, INSTRUCTION [E215E]
901209E215
103 * 4-072-417-01 CUSHION (UPPER)
DESCRIPTION
REMARK
104 * 4-072-418-01 CUSION (LOWER)
105 * 4-079-271-01 INDIVIDUAL CARTON [E220E]
9001097C2V
#1 105 * 4-079-570-01 INDIVIDUAL CARTON [E220]
9001097C1N
#1 105 * 4-080-496-01 INDIVIDUAL CARTON [E215E]
900109E215
6-3
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
NOTE:
CPD-E220/E220E/E215E
SECTION 7
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
DESCRIPTION
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
(a)
ELECTRICAL PARTS LIST
REMARK
REF.NO.
PARThave
NO. RESISTORS
DESCRIPTION
• All variable
and adjustable
resistors
characteristic curve B, unless otherwise • All resistors are in ohms
noted.
• F : nonflammable
REMARK
• Items marked " * " are not stocked since
they are seldom required for routine
service. Some delay should be anticipated
when ordering these items.
Les composants identifiés par une
marque ¡ sont critiques pour la
sécurité. Ne les remplacer que par une
pièce portant le numéro spécifié.
When indicating parts by reference
number, please include the board name.
REF.NO. PART NO.
DESCRIPTION
REF.NO. PART NO.
REMARK
A BOARD, COMPLETE
***************************
DESCRIPTION
REMARK
#4 C103
#4 C104
C106
1-163-189-11 CERAMIC
0.1µF
1-163-189-11 CERAMIC
0.1µF
1-135-383-11 METALIZED FILM 0.1µF
50V 7146104456
50V 7146104456
100V 5075104501
#4 C107
#4 C201
C202
#4 C203
#4 C204
1-136-165-11
1-135-791-11
1-126-964-11
1-163-189-11
1-163-189-11
METALIZED FILM 0.1µF
33pF
ELECT
10µF
CERAMIC
0.1µF
CERAMIC
0.1µF
50V
50V
50V
50V
50V
5134104452
7183330556
5156100T50
7146104456
7146104456
C206
#4 C207
#4 C301
C302
#4 C303
1-135-383-11
1-136-165-11
1-135-791-11
1-126-964-11
1-163-189-11
METALIZED FILM 0.1µF
METALIZED FILM 0.1µF
33pF
ELECT
10µF
CERAMIC
0.1µF
100V
50V
50V
50V
50V
5075104501
5134104452
7183330556
5156100T50
7146104456
#4 C304
C306
#4 C307
1-163-189-11 CERAMIC
0.1µF
1-135-383-11 METALIZED FILM 0.1µF
1-136-165-11 METALIZED FILM 0.1µF
4-382-854-11 SCREW (M3X10), P, SW (+) (IC002)
<CAPACITOR>
C001
C002
#4 C004
C005
#4 C006
1-126-964-11
1-126-934-11
1-115-340-11
1-135-397-11
1-163-189-11
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
10µF
220µF
0.22µF
47µF
0.1µF
50V
16V
16V
16V
50V
5156100T50
5156221S16
7144224106
515X470T16
7146104456
#4 C008
#4 C009
#4 C010
C011
#4 C012
1-136-165-11
1-126-947-11
1-163-189-11
1-128-582-11
1-130-777-11
METALIZED FILM
ELECT
CERAMIC
ELECT
PETP FILM
0.1µF
47µF
0.1µF
10µF
0.1µF
50V
16V
50V
100V
100V
5134104452
5156470T16
7146104456
5156100T01
5116104111
#4 C013
#4 C014
C015
C016
#4 C017
1-163-189-11
1-137-877-11
1-107-823-11
1-163-009-11
1-130-777-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
PETP FILM
0.1µF
1000pF
0.47µF
0.001µF
0.1µF
50V
2KV
16V
50V
100V
7146104456
51011021C3
7144474106
7144102256
5116104111
#4 C019
C022
C023
#4 C025
#4 C026
1-130-777-11
1-163-131-00
1-135-393-11
1-163-189-11
1-164-161-91
PETP FILM
CERAMIC
ELECT
CERAMIC
CERAMIC
0.1µF
390pF
100µF
0.1µF
2200pF
100V
50V
10V
50V
50V
5116104111
7183391556
5156101T10
7146104456
7144222156
C028
C029
C030
C032
#4 C033
1-163-263-11
1-102-074-21
1-135-393-11
1-135-398-11
1-163-017-11
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
330pF
0.001µF
100µF
1µF
4700pF
50V
50V
10V
50V
50V
7183331556
5101102152
5156101T10
5156109T50
7144472156
#4 C034
C035
#4 C037
#4 C038
#4 C039
1-163-189-11
1-135-393-11
1-115-340-11
1-126-947-11
1-104-665-91
CERAMIC
ELECT
CERAMIC
ELECT
ELECT
0.1µF
100µF
0.22µF
47µF
100µF
50V
10V
16V
16V
16V
7146104456
5156101T10
7144224106
5156470T16
5156101T16
D001
D002
D003
D004
D017
8-719-911-19
8-719-070-90
8-719-109-85
8-719-911-19
8-719-074-13
DIODE 1SS119-25
DIODE 1N4148
ZENER DIODE RD5.1ESB2
DIODE 1SS119-25
DIODE BYV26C
4120511900
412014148T
41205005C2
4120511900
413010426C
#4 C040
C042
C043
#4 C044
C045
1-137-150-11
Pending
1-135-404-11
1-130-777-11
Pending
PETP FILM
CERAMIC
ELECT
PETP FILM
CERAMIC
0.01µF
33pF
4.7µF
0.1µF
0.01µF
100V 5116103511
50V 5121330552
35V 5162479T35
100V 5116104111
1.5KV 5104103463
D101
D102
D103
D104
D105
8-719-070-90
8-719-070-90
8-719-970-82
8-719-970-82
8-719-970-82
DIODE 1N4148
DIODE 1N4148
DIODE HSS82
DIODE HSS82
DIODE HSS82
412014148T
412014148T
4130190820
4130190820
4130190820
#4 C101
C102
1-135-791-11
1-126-964-11 ELECT
33pF
10µF
50V
50V
D201
D202
8-719-911-19 DIODE 1SS119-25
8-719-911-19 DIODE 1SS119-25
50V 7146104456
100V 5075104501
50V 5134104452
<CONNECTOR>
CN301 1-564-510-81
CN302 1-564-510-81
CN303* 1-564-510-81
CN304* 1-564-507-11
CN307 1-695-915-11
PLUG, CONNECTOR 6P
PLUG, CONNECTOR 9P
PLUG, CONNECTOR 7P
PLUG, CONNECTOR 4P
TAB (CONTACT)
1P
CN309 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN)
CN310 1-695-915-11 TAB (CONTACT)
1P
CN311
Pending
1P
CN312
Pending
1P
4490600330
4490900330
4490700330
4490400330
3340236016
<DIODE>
7183330556
5156100T50
7-1
4120511900
4120511900
CPD-E220/E220E/E215E
(a)
REF.NO. PART NO.
DESCRIPTION
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
REMARK
D203
D204
D205
8-719-970-82 DIODE HSS82
8-719-970-82 DIODE HSS82
8-719-970-82 DIODE HSS82
4130190820
4130190820
4130190820
D301
D302
D303
D304
D305
8-719-911-19
8-719-911-19
8-719-970-82
8-719-970-82
8-719-970-82
4120511900
4120511900
4130190820
4130190820
4130190820
DIODE 1SS119-25
DIODE 1SS119-25
DIODE HSS82
DIODE HSS82
DIODE HSS82
REF.NO. PART NO.
1-414-793-21
1-469-611-11
1-535-303-31
1-535-303-31
1-535-303-31
BEAD, FERRITE 0.45µH
INDUCTOR, FERRITE BEAD 2µH
JUMP WIRE
JUMP WIRE
JUMP WIRE
FB006 1-469-402-11 BEAD, FERRITE 3µH
#4 FB101 1-535-303-31 JUMP WIRE
#4 FB201 1-535-303-31 JUMP WIRE
#4 FB301 1-535-303-31 JUMP WIRE
DESCRIPTION
REMARK
<RESISTOR>
<FERRITE BEAD>
#4 FB001
FB002
#4 FB003
#4 FB004
#4 FB005
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
7099458250
4322209005
5406100000
5406100000
5406100000
4322309006
5406100000
5406100000
5406100000
R001
R002
R004
#4 R005
R006
1-247-807-31
1-247-807-31
1-216-025-11
1-215-049-91
1-216-073-91
CARBON (SMALL) 100
CARBON (SMALL) 100
RES-CHIP
100
RES-CHIP
1K
RES-CHIP
10K
1/4W 4050510155
1/4W 4050510155
1/10W 4010110152
1/10W 4010110252
1/10W 4010110352
R007
#4 R008
#4 R009
R010
#4 R011
1-216-025-11
1-216-660-11
1-215-049-91
1-216-025-11
1-216-041-11
RES-CHIP
RES, CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
2.4K
1K
100
470
1/10W 4010110152
1/10W 4010124252
1/10W 4010110252
1/10W 4010110152
1/10W 4010147152
#4 R012
R013
R014
R015
#4 R016
1-215-049-91
1-216-065-11
1-216-065-11
1-247-816-11
1-216-041-11
RES-CHIP
1K
RES-CHIP
4.7K
RES-CHIP
4.7K
CARBON (SMALL) 240
RES-CHIP
470
1/10W 4010110252
1/10W 4010147252
1/10W 4010147252
1/4W 4050524155
1/10W 4010147152
R017
R018
R019
R020
#4 R021
1-247-807-31
1-216-025-11
1-216-025-11
Pending
1-244-297-11
CARBON (SMALL) 100
RES-CHIP
100
RES-CHIP
100
METAL FILM 4.42K
RES-CHIP
32.4K
1/4W 4050510155
1/10W 4010110152
1/10W 4010110152
1/4W 4257044421
1/10W 419A132422
#4
#4
#4
#4
#4
R022
R023
R024
R025
R026
1-216-660-11
1-216-121-11
1-247-883-11
1-249-421-11
1-216-041-11
RES, CHIP
2.4K
RES-CHIP
1M
CARBON (SMALL) 150K
CARBON (SMALL) 2.2K
RES-CHIP
470
1/10W 4010124252
1/10W 4010110552
1/4W 4050515455
1/4W 4050522255
1/10W 4010147152
#4 R027
#4 R028
R029
R030
#4 R031
1-215-049-91
1-215-049-91
1-216-053-11
1-216-073-91
1-244-274-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL FILM
1K
1K
1.5K
10K
22M
1/10W 4010110252
1/10W 4010110252
1/10W 4010115252
1/10W 4010110352
1/4W 4160422655
#4 R032
#4 R033
R034
#4 R035
#4 R036
1-215-049-91
1-216-105-11
Pending
1-244-273-11
1-216-025-11
RES-CHIP
RES-CHIP
1K
220K
10K
2.2M
100
1/10W 4010110252
1/10W 4010122452
1/2W 4050210355
1/2W 4160222555
1/10W 4010110152
#4 R037
#4 R039
R042
#4 R046
R049
1-216-025-11
1-216-660-11
Pending
1-216-662-11
1-216-073-91
RES-CHIP
RES, CHIP
RES-CHIP
RES-CHIP
100
2.4K
100
3K
10K
1/10W 4010110152
1/10W 4010124252
1/2W 4050210155
1/10W 4010130252
1/10W 4010110352
R050
R051
#4 R054
R101
#4 R103
1-216-065-11
1-216-053-11
1-216-121-11
1-216-022-11
1-215-049-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
1.5K
1M
75
1K
1/10W 4010147252
1/10W 4010115252
1/10W 4010110552
1/10W 4010175002
1/10W 4010110252
#4
#4
#4
#4
1-249-393-11
1-249-425-11
1-247-862-11
1-216-041-11
1-247-903-81
CARBON (SMALL) 12
CARBON (SMALL) 4.7K
CARBON (SMALL) 20K
RES-CHIP
470
CARBON (SMALL) 1M
1/4W 4050512055
1/4W 4050547255
1/4W 4050520355
1/10W 4010147152
1/4W 4050510555
<IC>
IC001 8-759-582-06 IC M52743BSP
IC002 8-759-569-64 IC BH3863F
IC003
Pending
IC M35047-XXX
IC004 8-759-991-16 IC LM358N
4159527432
4159350470
4159358000
<SOCKET, PICTURE TUBE>
J001 0 1-251-598-11 SOCKET, PICTURE TUBE
4570307Y11
<COIL>
L001
#4 L002
L101
#4 L102
L201
1-469-400-11
1-535-303-31
1-469-398-11
1-419-618-11
1-469-398-11
INDUCTOR, MICRO 100µH
JUMP WIRE
INDUCTOR, MICRO 0.1µH
INDUCTOR, MICRO 0.47µH
INDUCTOR, MICRO 0.1µH
432B101006
5406100000
432B108006
432B478006
432B108006
#4 L202
L301
#4 L302
1-419-618-11 INDUCTOR, MICRO 0.47µH
1-469-398-11 INDUCTOR, MICRO 0.1µH
1-419-618-11 INDUCTOR, MICRO 0.47µH
432B478006
432B108006
432B478006
<TRANSISTOR>
Q001
Q002
Q003
Q004
#4 Q005
8-729-139-04
8-729-139-04
8-729-139-04
8-729-823-81
8-729-029-86
TRANSISTOR 2N3904
TRANSISTOR 2N3904
TRANSISTOR 2N3904
TRANSISTOR 2SC4632LS-CB7
TRANSISTOR DTC124ESA
4111139040
4111139040
4111139040
4100246340
4116612030
Q008
#4 Q101
#4 Q201
#4 Q301
8-729-139-04
8-729-048-20
8-729-048-20
8-729-048-20
TRANSISTOR 2N3904
TRANSISTOR BF420
TRANSISTOR BF420
TRANSISTOR BF420
4111139040
4114804200
4114804200
4114804200
R104
R107
R108
R109
R111
R112
R113
R115
R201
#4 R203
7-2
METAL FILM
RES-CHIP
Pending
1-216-013-11 RES-CHIP
Pending
1-216-022-11 RES-CHIP
1-215-049-91 RES-CHIP
300
33
62
75
1K
1/2W 4050230155
1/10W 4010133052
1/2W 4050262055
1/10W 4010175002
1/10W 4010110252
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
#4
#4
#4
#4
R204
R207
R208
R209
R211
1-249-393-11
1-249-425-11
1-247-862-11
1-249-413-11
1-247-903-81
DESCRIPTION
CARBON (SMALL) 12
CARBON (SMALL) 4.7K
CARBON (SMALL) 20K
CARBON (SMALL) 470
CARBON (SMALL) 1M
R212
R213
R215
R301
#4 R302
Pending
1-216-013-11 RES-CHIP
Pending
1-216-022-11 RES-CHIP
1-535-303-31 JUMP WIRE
#4
#4
#4
#4
#4
R303
R304
R307
R308
R309
1-215-049-91
1-249-393-11
1-249-425-11
1-247-862-11
1-249-413-11
R311
R312
R313
R315
1-247-903-81 CARBON (SMALL) 1M
Pending
300
1-216-013-11 RES-CHIP
33
Pending
62
CPD-E220/E220E/E215E
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
300
33
100
75
RES-CHIP
1K
CARBON (SMALL) 12
CARBON (SMALL) 4.7K
CARBON (SMALL) 20K
CARBON (SMALL) 470
REMARK
1/4W
1/4W
1/4W
1/4W
1/4W
(a)(d)
REF.NO. PART NO.
4050512055
4050547255
4050520355
4050547155
4050510555
1/2W 4050230155
1/10W 4010133052
1/2W 4050210155
1/10W 4010175002
5406100000
1/10W 4010110252
1/4W 4050512055
1/4W 4050547255
1/4W 4050520355
1/4W 4050547155
REMARK
#4 C507
C508
1-136-287-11 PETP FILM
1-163-251-11 CERAMIC
0.0047µF
100pF
100V 5116472511
50V 7183101556
C509
#4 C510
C512
C513
#4 C514
Pending
1-107-914-11
1-163-251-11
1-163-251-11
1-163-189-11
ELECT
CERAMIC
CERAMIC
CERAMIC
0.0033µF
1000µF
100pF
100pF
0.1µF
50V
16V
50V
50V
50V
5144332550
5153102S25
7183101556
7183101556
7146104456
C515
C517
#4 C518
C521
#4 C522
1-136-195-11
1-128-981-11
1-137-876-11
Pending
Pending
METALIZED FILM 0.022µF
CERAMIC
220pF
CERAMIC
1500pF
4300pF
FILM
0.24µF
250V
3KV
1KV
2KV
250V
5074223102
510H221193
5101152132
51904323A3
5199244583
[E220/E220E]
#4 C522
Pending
FILM
250V 5199334583
[E215E]
50V 5156100T50
250V 5198124583
[E220/E220E]
250V 5198184583
[E215E]
250V 5198104583
[E220/E220E]
C523
#4 C524
1/4W 4050510555
1/2W 4050230155
1/10W 4010133052
1/2W 4050262055
DESCRIPTION
#4 C524
#4 C525
1-126-964-11 ELECT
1-117-660-21 PETP FILM
Pending
PETP FILM
1-117-659-21 PETP FILM
0.33µF
10µF
0.12µF
0.18µF
0.1µF
<SPARK GAP>
#4 SG001 1-135-791-11 SPARK GAP
SG101
Pending
SPARK GAP
SG201
Pending
SPARK GAP
SG301
Pending
SPARK GAP
7183330556
4700000003
4700000003
4700000003
******************************************************************************************
D BOARD, COMPLETE
***************************
1-500-644-11 INDUCTOR (D521, D623, D627)
1-506-108-41 PIN, CONNECTOR (TERMINAL PIN)
(CN503, R530, R603, R614, R653)
1-533-223-11 HOLDER, FUSE (F601)
46905Y1101
1-785-907-11 PLUG, CONNECTOR 1P
(R576, R583, R605, R653) 3340101525
4-382-854-01 SCREW (M3X8), P, SW (+)
(C409, IC605, IC607, Q503, Q506, Q508,
Q517, Q518, Q519, Q534, Q544, Q602)
<CAPACITOR>
#4 C525
Pending
PETP FILM
0,24µF
#4 C528
1-163-017-11 CERAMIC
#4 C529
1-136-165-11 METALIZED FILM 0.1µF
250V 5198244583
[E215E]
250V 5190334583
[E220/E220E]
50V 7144472156
[E220/E220E]
50V 5134104452
#4 C526
Pending
PETP FILM
0.33µF
#4 C531
#4 C532
C533
#4 C534
#4 C535
1-137-150-11
1-137-962-11
1-126-961-11
1-163-189-11
1-104-665-91
PETP FILM
METALIZED FILM
ELECT
CERAMIC
ELECT
0.01µF
0.047µF
2.2µF
0.1µF
100µF
100V
100V
50V
50V
16V
C536
#4 C537
C539
#4 C540
C541
Pending
1-137-878-11
1-128-563-11
1-163-189-11
1-135-395-11
CERAMIC
ELECT
CERAMIC
ELECT
1500pF
3900pF
68µF
0.1µF
4.7µF
1.6KV 5192152573
1KV 5101392132
100V 5156680T01
50V 7146104456
50V 5156479T50
C542
#4 C543
C545
C546
C547
1-137-395-91
1-137-873-11
1-126-964-11
Pending
Pending
PETP FILM
CERAMIC
ELECT
CERAMIC
METALIZED FILM
0.022µF
1000pF
10µF
100pF
0.1µF
100V
100V
50V
50V
50V
5116223111
5101102112
5156100T50
5101101152
5077104505
4700pF
5116103511
5074473101
5156229T50
7146104456
5156101T16
C401
C402
C403
#4 C404
#4 C405
1-137-395-91
1-128-528-51
1-137-395-91
1-107-914-11
1-130-499-11
METALIZED FILM
ELECT
PETP FILM
ELECT
PETP FILM
0.1µF
470µF
0.022µF
1000µF
0.22µF
250V
25V
100V
25V
50V
5074104102
5156471S25
5116223111
5153102S25
5110224550
C548
C549
C550
#4 C553
C554
Pending
Pending
1-135-352-11
1-163-133-21
Pending
ELECT
330µF
ELECT
330µF
METALIZED FILM 0.01µF
470pF
CERAMIC
470pF
25V
25V
250V
50V
50V
5156331T25
5156331T25
5074103102
7183471556
5128471552
#4 C406
C408
#4 C409
C502
C503
1-136-298-11
1-126-951-11
1-104-987-11
Pending
Pending
PETP FILM
ELECT
PE TEREPHTHALATE
METALIZED FILM
METALIZED FILM
0.0033µF
470µF
0.001µF
0.1µF
0.1µF
100V
35V
100V
50V
50V
5116332111
5156471S35
5116102111
5077104505
5077104505
#4 C555
#4 C556
#4 C558
C559
#4 C560
1-136-165-11
1-163-189-11
1-137-352-11
1-136-684-51
1-163-189-11
METALIZED FILM
CERAMIC
PETP FILM
PETP FILM
CERAMIC
0.1µF
0.1µF
0.0033µF
0.0022µF
0.1µF
50V
50V
100V
100V
50V
5134104452
7146104456
5116333111
5116222111
7146104456
#4 C504
C505
#4 C506
1-137-150-11 PETP FILM
0.01µF
Pending
METALIZED FILM 0.1µF
1-137-150-11 PETP FILM
0.01µF
100V 5116472511
50V 5077104505
100V 5116103511
#4 C561
#4 C562
#4 C563
1-163-007-11
1-163-189-11 CERAMIC
1-104-661-91 ELECT
680pF
0.1µF
330µF
50V
50V
16V
7144681156
7146104456
5156331T16
7-3
CPD-E220/E220E/E215E
(d)
REF.NO. PART NO.
#4 C564
#4 C565
C566
C567
#4 C568
DESCRIPTION
1-126-947-11 ELECT
1-107-651-11 ELECT
REMARK
REF.NO. PART NO.
47µF
4.7µF
25V 5156470T25
250V 5156479S03
C625
C626
1µF
0.01µF
1000pF
#4 C628
C630
#4 C631
C632
#4 C633
C570
#4 C571
#4 C572
1-126-964-11 ELECT
1-163-189-11 CERAMIC
1-126-947-11 ELECT
10µF
0.1µF
47µF
250V 5190105583
2KV 51041034C3
50V 7144102156
[E220/E220E]
50V 5156100T50
50V 7146104456
16V 5156470T16
#4
#4
#4
#4
#4
C573
C574
C575
C576
C577
1-135-404-11
1-126-970-11
1-163-031-91
1-163-189-11
1-107-662-11
ELECT
ELECT
CERAMIC
ELECT
4.7µF
330µF
0.01µF
0.1µF
22µF
35V
50V
50V
50V
250V
5162479T35
5156331S50
7146103456
7146104456
5156220S03
#4 C580
#4 C581
#4 C582
C583
#4 C584
1-130-499-11
1-130-499-11
1-128-564-91
Pending
Pending
PETP FILM
PETP FILM
ELECT
ELECT
CERAMIC
0.22µF
0.22µF
220µF
4.7µF
470pF
50V
50V
100V
100V
50V
5110224550
5110224550
5156221T01
515X479T01
7144471156
[E220/E220E]
#4 C584
Pending
CERAMIC
680pF
50V
C585
C589
#4 C590
#4 C591
Pending
1-135-398-11
1-163-189-11
1-163-189-11
CERAMIC
ELECT
CERAMIC
CERAMIC
1000pF
1µF
0.1µF
0.1µF
7144681156
[E215E]
500V 5101102142
50V 5156109T50
50V 7146104456
50V 7146104456
#4 C592
C593
#4 C594
1-135-404-11 ELECT
Pending
PETP FILM
Pending
CERAMIC
4.7µF
0.22µF
470pF
35V
50V
50V
#4 C594
#4 C595
Pending
Pending
Pending
Pending
CERAMIC
CERAMIC
CERAMIC
680pF
1-137-871-11 METALIZED FILM 0.1µF
5162479T35
5113224150
7144471156
[E220/E220E]
50V 7144681156
[E215E]
400V 5074104104
#4 C598 1-163-189-11 CERAMIC
C599 1-126-969-11 ELECT
#4 C601 0 1-113-511-11
#4 C602 0 1-113-511-11
C603 0 1-135-380-11 CERAMIC
0.1µF
220µF
0.47µF
0.47µF
470pF
50V
50V
250V
250V
250V
7146104456
5156221T50
5067474425
5067474425
5063471325
C604 0 1-135-380-11
C605 1-135-351-11
C606 1-135-396-11
#4 C607 1-126-949-11
#4 C608 1-137-871-11
470pF
4700pF
220µF
220µF
0.1µF
250V
250V
450V
35V
400V
5063471325
5063472425
515P331S45
5156221T35
5074104104
CERAMIC
CERAMIC
ELECT
ELECT
METALIZED FILM
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
#4 C609
Pending
METALIZED FILM 0.33µF
#4 C611
#4 C612
1-163-007-11
1-137-150-11 PETP FILM
680pF
0.01µF
630V 5074334106
[E220/E220E]
630V 5074224106
[E215E]
50V 7144681156
100V 5116103511
#4 C609
Pending
METALIZED FILM 0.22µF
#4 C613
#4 C614
#4 C616
C618
#4 C619
1-163-002-11
1-163-189-11
1-163-189-11
1-126-964-11
1-163-189-11
CERAMIC
CERAMIC
ELECT
CERAMIC
270pF
0.1µF
0.1µF
10µF
0.1µF
50V
50V
50V
50V
50V
#4 C620
C622
#4 C623
1-135-389-11 CERAMIC
Pending
1-163-251-11 CERAMIC
100pF
0.22µF
100pF
1KV 510H101132
50V 5113224150
50V 7183101556
DESCRIPTION
REMARK
1-125-700-11 ELECT
1-107-955-51 ELECT
220µF
100µF
100V 5156221S01
250V 515X101S03
1-107-914-11
1-128-528-51
1-163-189-11
1-128-528-51
1-107-914-11
ELECT
ELECT
CERAMIC
ELECT
ELECT
1000µF
470µF
0.1µF
470µF
1000µF
25V
25V
50V
25V
25V
5153102S25
5156471S25
7146104456
5156471S25
5153102S25
C634 1-107-884-81
#4 C635 1-126-926-11
C638 1-164-143-11
#4 C640 0 1-115-165-11
#4 C643 1-163-189-11
ELECT
ELECT
CERAMIC
CAP, FILM
CERAMIC
1000µF
1000µF
1000pF
0.1µF
0.1µF
16V
10V
1KV
250V
50V
5156102S16
5156102S10
5101102132
5067104425
7146104456
C645 1-126-935-91
#4 C646 1-107-914-11
C647 1-135-401-11
#4 C648 0 1-137-930-11
#4 C649 0 1-137-930-11
ELECT
ELECT
ELECT
CERAMIC
CERAMIC
470µF
1000µF
100µF
4700pF
4700pF
16V
25V
35V
400V
400V
5156471T16
5153102S25
5156101T35
5061472440
5061472440
#4 C650
Pending
METALIZED FILM 0.022µF
#4 C650
Pending
METALIZED FILM 0.01µF
C651
C652
C654
C655
1-107-914-11
1-137-972-11
1-128-551-11
1-107-636-11
ELECT
METALIZED FILM
ELECT
ELECT
1000µF
0.22µF
22µF
10µF
630V 5074223106
[E220 [NH]/E220E]
630V 5074103106
[E215E]
25V 5153102S25
250V 5077224102
25V 5156220T25
160V 5156100T02
C902
C903
C904
C905
C906
1-126-961-11
1-126-961-11
1-126-961-11
1-126-961-11
1-126-961-11
ELECT
ELECT
ELECT
ELECT
ELECT
2.2µF
2.2µF
2.2µF
2.2µF
2.2µF
50V
50V
50V
50V
50V
5156229T50
5156229T50
5156229T50
5156229T50
5156229T50
C907
C908
C909
C910
C914
1-126-964-11
1-163-189-11
1-163-133-21
1-163-189-11
1-163-251-11
ELECT
CERAMIC
CERAMIC
CERAMIC
10µF
0.1µF
470pF
0.1µF
100pF
50V
50V
50V
50V
50V
5156100T50
7146104456
7183471556
7146104456
7183101556
#4 C915
1-102-973-21 CERAMIC
100pF
50V
#4
#4
#4
#4
1-163-243-11
1-163-243-11
1-163-189-11 CERAMIC
1-163-235-91
47pF
47pF
0.1µF
22pF
50V
50V
50V
50V
5128101552
[E220/E220E]
7183470556
7183470556
7146104456
7183220556
#4 C922
C923
#4 C924
#4 C925
#4 C926
1-163-235-91
1-126-961-11
1-135-395-11
1-163-189-11
1-163-251-11
ELECT
ELECT
CERAMIC
CERAMIC
22pF
2.2µF
4.7µF
0.1µF
100pF
50V
50V
50V
50V
50V
7183220556
5156229T50
5156479T50
7146104456
7183101556
#4 C927
1-163-251-11 CERAMIC
100pF
50V
7183101556
#4
#4
#4
#4
#4
#4
#4
#4
C918
C919
C920
C921
<CONNECTOR>
7144271156
7146104456
7146104456
5156100T50
7146104456
CN501
Pending
6P
CN502
Pending
4P
#4 CN503 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN)
CN504
#4 CN505
7-4
Pending
1P
2P
3340236016
[E220E/E215E]
C488020185
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
CPD-E220/E220E/E215E
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
DESCRIPTION
REMARK
(d)
REF.NO. PART NO.
DESCRIPTION
#4 CN60101-251-227-11 AC SOCKET
#4 CN602 1-815-267-11 PIN, CONNECTOR 3P
CN603
Pending
7P
CN901
Pending
9P
#4 CN902 1-564-510-51 PLUG, CONNECTOR 7P
4570707C00
4490301100
D615
D616
D617
4490700330
CN903* 1-564-507-11 PLUG, CONNECTOR 4P
4490400330
#4 D618
D619
#4 D621
8-719-074-17 DIODE SR1003
8-719-911-19 DIODE 1SS119-25
8-719-074-13 DIODE BYV26C
D622
#4 D623
8-719-074-19 DIODE UF5402G
8-719-048-23 DIODE UF5406
#4 D625
D626
#4 D627
8-719-911-19 DIODE 1SS119-25
8-719-911-19 DIODE 1SS119-25
8-719-048-23 DIODE UF5406
#4 D628
D629
8-719-048-23 DIODE UF5406
8-719-911-19 DIODE 1SS119-25
<DIODE>
D402
D501
D502
D503
D504
8-719-200-02
8-719-911-19
8-719-110-39
8-719-052-86
8-719-911-19
DIODE 10E2
DIODE 1SS119-25
ZENER DIODE RD15ES-B1
DIODE D2L40-TA
DIODE 1SS119-25
4120104002
4120511900
4130152400
4120511900
D506
D507
D508
#4 D509
D510
8-719-911-19
8-719-987-31
Pending
8-719-083-88
8-719-911-19
DIODE 1SS119-25
DIODE SB140-6339
DIODE 5TUZ47CTO-220NIS
DIODE PS104R
DIODE 1SS119-25
4120511900
4130104140
413050Z470
4130101040
4120511900
#4 D511
#4 D512
D513
D514
D515
8-719-083-88
8-719-083-88
8-719-074-13
8-719-074-25
8-719-074-13
DIODE PS104R
DIODE PS104R
DIODE BYV26C
DIODE PG104R
DIODE BYV26C
4130101040
4130101040
413010426C
4130101041
413010426C
#4 D516
D517
D518
#4 D519
D520
8-719-911-19
8-719-911-19
8-719-911-19
8-719-083-88
8-719-074-25
DIODE 1SS119-25
DIODE 1SS119-25
DIODE 1SS119-25
DIODE PS104R
DIODE PG104R
4120511900
4120511900
4120511900
4130101040
4130101041
D521
D522
D523
D524
D525
Pending
8-719-074-25
8-719-911-19
8-719-911-19
8-719-921-42
DIODE BYV26C-200
DIODE PG104R
DIODE 1SS119-25
DIODE 1SS119-25
ZENER DIODE MTZJ-5.1A
4130204270
4130101041
4120511900
4120511900
41205005C1
D526
#4 D527
#4 D528
D530
D531
8-719-911-19
8-719-110-35
8-729-074-16
8-719-911-19
8-719-911-19
DIODE 1SS119-25
ZENER DIODE HZ12
DIODE RGP02-18
DIODE 1SS119-25
DIODE 1SS119-25
4120511900
4120501202
4130100218
4120511900
4120511900
#4 D532
D533
D535
D538
D592
8-729-077-81
8-719-911-19
8-719-921-42
8-719-110-39
8-719-911-19
ZENER DIODE Z10-160B
DIODE 1SS119-25
DIODE MTZJ-5.1A
ZENER DIODE RD15ES-B1
DIODE 1SS119-25
D601 0 8-719-510-53
D603 8-719-911-19
#4 D604 8-719-083-88
D605 8-719-053-19
D606 8-719-911-19
DIODE D4SB60L
DIODE 1SS119-25
DIODE PS104R
DIODE UF4007G23
DIODE 1SS119-25
4130400600
4120511900
4130101040
413010426D
4120511900
#4 D607
#4 D608
D609
D610
D611
8-719-154-15
8-719-154-15
8-719-911-19
8-719-911-19
8-719-911-19
ZENER DIODE RD27EB4
ZENER DIODE RD27EB4
DIODE 1SS119-25
DIODE 1SS119-25
DIODE 1SS119-25
4120502705
4120502705
4120511900
4120511900
4120511900
D612
#4 D613
8-719-911-55 DIODE U05G
8-719-048-23 DIODE UF5406
REMARK
8-719-077-80 DIODE UF5404G
8-719-074-19 DIODE UF5402G
8-719-074-25 DIODE PG104R
4130305404
4130305402
4130101041
4120511900
413010426C
[E220 [NH]/E220E/E215E]
4130305402
4130305406
[E220 [NH]/E220E/ E215E]
4120511900
4120511900
4130305406
[E220 [NH]/E220E/E215E]
4130305406
4120511900
D630
D631
D901
D902
D903
8-719-911-19
8-719-077-80
8-719-921-42
8-719-921-42
8-719-921-42
DIODE 1SS119-25
DIODE UF5404G
ZENER DIODE MTZJ-5.1A
ZENER DIODE MTZJ-5.1A
ZENER DIODE MTZJ-5.1A
4120511900
4130305404
41205005C1
41205005C1
41205005C1
D904
D905
D906
D908
8-719-921-42
8-719-921-42
8-719-921-42
8-719-911-19
ZENER DIODE MTZJ-5.1A
ZENER DIODE MTZJ-5.1A
ZENER DIODE MTZJ-5.1A
DIODE 1SS119-25
41205005C1
41205005C1
41205005C1
4120511900
<FUSE>
F601 0 1-576-231-11 FUSE (H.B.C.) (4A/250V)
5268400052
<FERRITE BEAD>
FB502
FB504
FB507
FB508
FB604
1-419-981-11
1-469-402-11
1-412-911-11
1-412-911-11
1-469-611-11
COIL, CHOKE 10.8µH
BEAD, FERRITE 3µH
BEAD, FERRITE 2.3µH
BEAD, FERRITE 2.3µH
BEAD, FERRITE 2µH
4120510160
4120511900
FB605
#4 FB606
FB607
FB608
#4 FB609
1-469-611-11
1-469-611-11
1-469-611-11
1-469-611-11
Pending
BEAD, FERRITE 2µH
BEAD, FERRITE 2µH
BEAD, FERRITE 2µH
BEAD, FERRITE 2µH
BEAD, FERRITE 3µH
41205015AU
4120511900
#4 FB610
Pending
BEAD, FERRITE 3µH
4323100103
4322309006
7099159250
7099159250
4322309504
4322309504
4322309504
4322309504
4322309504
4322309504
[E220 [NH]/E220E/E215E]
4322309504
[E220 [NH]/E220E/E215E]
#4 FB611
Pending
BEAD, FERRITE 3µH
4322309504
[E220 [NH]/E220E/E215E]
FB612 1-419-445-11 COIL, CHOKE 300µH
7065R10301
FB613 1-419-445-11 COIL, CHOKE 300µH
7065R10301
#4 FB614
Pending
BEAD, FERRITE 1.5µH
7099159250
[E220 [NH]/E220E/E215E]
FB620 1-469-611-11 BEAD, FERRITE 2µH
FB622 1-469-611-11 BEAD, FERRITE 2µH
FB624 1-469-611-11 BEAD, FERRITE 2µH
4120104004
4130305406
7-5
4322309504
4322309504
4322309504
CPD-E220/E220E/E215E
(d)
REF.NO. PART NO.
DESCRIPTION
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
REMARK
REF.NO. PART NO.
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
DESCRIPTION
REMARK
<IC>
IC401 8-759-593-28 IC LA78040
IC501
Pending
IC TDA4841
IC502
Pending
IC UC3843A
IC504 8-759-991-16 IC LM358N
IC601 8-759-582-09 IC UC3842A
IC602
IC603
IC604
IC605
IC606
8-749-016-36
8-759-466-12
8-729-051-32
8-759-231-53
8-729-048-22
IC TLP621D4-Y-LF2
IC TL431ACLP
TRANSISTOR MCR100-8RL
IC TA7805S
TRANSISTOR MCR100
#4 IC607 8-759-088-08 IC MCT7812CT
IC901
Pending
IC ST72774
IC902 8-759-650-44 IC M24C16BN6
IC903 8-759-605-05 IC M51951BSL
4159817200
4159484100
4159384300
4159358000
4159384200
415943100A
4114510080
4159780501
4114501006
4159781201
4159727750
415924C160
4159519510
#4 Q512
Q513
#4 Q514
#4 Q515
Q516
8-729-194-57
8-729-141-03
8-729-194-57
8-729-194-57
8-729-141-03
TRANSISTOR 2SC945-P
TRANSISTOR 2SA733-QP
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR 2SA733-QP
411020945P
4110007330
411020945P
411020945P
4110007330
Q517
#4 Q518
Q519
#4 Q520
8-729-306-92
8-729-304-92
8-729-119-80
8-729-194-57
TRANSISTOR 2SD669AVC
TRANSISTOR 2SB649-C
TRANSISTOR 2SC2688-LK
TRANSISTOR 2SC945-P
#4 Q521
8-729-141-03 TRANSISTOR 2SA733-QP
410030669A
410010649A
4100226880
411020945P
[E220/E220E]
4110007330
[E220/E220E]
Q522
Q523
Q524
Q525
#4 Q526
8-729-048-61
8-729-306-92
8-729-906-93
8-729-141-03
8-729-029-86
TRANSISTOR 2SK2843LB2SONY
TRANSISTOR 2SD669AVC
TRANSISTOR IRF640
TRANSISTOR 2SA733-QP
TRANSISTOR DTC124ESA
4101528430
410030669A
4105906400
4110007330
4116612030
#4 Q527
#4 Q528
#4 Q529
Q530
Q531
8-729-194-57
8-729-194-57
8-729-194-57
8-729-119-80
8-729-051-31
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR 2SC2688-LK
TRANSISTOR KSP92
411020945P
411020945P
411020945P
4100226880
4112409200
Q532
Q533
#4 Q534
Q535
Q536
8-729-141-03
8-729-141-03
8-729-194-57
8-729-029-86
8-729-906-93
TRANSISTOR 2SA733-QP
TRANSISTOR 2SA733-QP
TRANSISTOR 2SC945-P
TRANSISTOR DTC124ESA
TRANSISTOR IRF640
4110007330
4110007330
411020945P
4116612030
4105906400
#4
#4
#4
#4
Q537
Q538
Q539
Q540
Q541
8-729-194-57
8-729-194-57
8-729-194-57
8-729-194-57
Pending
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR H2N6718L
411020945P
411020945P
411020945P
411020945P
4111167180
Q542
#4 Q543
#4 Q544
#4 Q546
8-729-122-12
8-729-055-78
8-729-055-77
8-729-029-86
TRANSISTOR 2SA1221-L
TRANSISTOR TIP122
TRANSISTOR TIP127
TRANSISTOR DTC124ESA
8-729-141-03 TRANSISTOR 2SA733-QP
411010647A
4103200122
4103200127
4116612030
[E220/E220E]
4110007330
Q602
#4 Q603
#4 Q604
Q607
Q608
8-729-040-92
8-729-194-57
8-729-029-86
8-729-200-36
8-729-206-21
TRANSISTOR 2SK2607
TRANSISTOR 2SC945-P
TRANSISTOR DTC124ESA
TRANSISTOR 2SA966-Y
TRANSISTOR RN1203
4102207800
411020945P
4116612030
4110009660
4116612030
Q609
#4 Q610
#4 Q611
#4 Q615
Q616
Pending
8-729-029-86
8-729-029-86
8-729-194-57
8-729-029-86
TRANSISTOR 2SB1065
TRANSISTOR DTC124ESA
TRANSISTOR DTC124ESA
TRANSISTOR 2SC945-P
TRANSISTOR DTC124ESA
4100110650
4116612030
4116612030
411020945P
4116612030
Q617
Q618
Q901
#4 Q902
8-729-265-52
8-729-141-03
8-729-139-04
8-729-139-04
TRANSISTOR 2SC2655
TRANSISTOR 2SA733-QP
TRANSISTOR 2N3904
TRANSISTOR 2N3904
4100226550
4110007330
4111139040
4111139040
[E220/E220E]
<COIL>
#4
#4
#4
#4
L501
L502
L503
L504
#4 L504
1-412-550-11
1-469-994-11
1-459-104-11
1-419-986-11
Pending
INDUCTOR, MICRO 1.2mH
COIL, PEAKING 100µH
COIL, CHOKE 10mH
COIL, CHOKE 28µH
COIL, CHOKE 25.5µH
#4
#4
#4
#4
#4
L505
L506
L509
L601
L602
1-419-568-11
1-459-104-11
1-469-995-11
1-412-537-31
1-412-537-31
COIL, LINEARITY
COIL, CHOKE 10mH
COIL, PEAKING 150µH
COIL, CHOKE 100µH
COIL, CHOKE 100µH
#4
#4
#4
#4
L603
L604
L605
L606
1-412-537-31
1-412-537-31
1-412-537-31
Pending
COIL, CHOKE 100µH
COIL, CHOKE 100µH
COIL, CHOKE 100µH
COIL, CHOKE 15µH
#4 L607
4323122003
4321101006
4323103003
4323280003
[E220/E220E]
4323255903
[E215E]
708S205R50
4323103003
4321151006
4323101303
4323101303
4323101303
4323101303
4323101303
7067C2U150
[E220 [NH]/E220E/E215E]
1-410-645-31 INDUCTOR, MICRO 100µH
4326101005
<FILTER>
Q601
LF6010 1-433-798-11 TRANSFORMER, LINE FILTER
7065Y11133
<TRANSISTOR>
Q401
Q501
#4 Q502
8-729-194-57 TRANSISTOR 2SC945-P
Pending
TRANSISTOR SFS9634
8-729-042-34 TRANSISTOR IRFU110
#4 Q502
Pending
TRANSISTOR 2SC2655-Y
Q503
Q504
Q505
#4 Q506
8-729-052-42
8-729-194-57
8-729-194-57
8-729-906-93
TRANSISTOR 2SC5587
TRANSISTOR 2SC945-P
TRANSISTOR 2SC945-P
TRANSISTOR IRF640
#4 Q508
8-729-194-57 TRANSISTOR 2SC945-P
Q510
Q511
8-729-141-03 TRANSISTOR 2SA733-QP
Pending
TRANSISTOR H2N6718L
411020945P
4107496340
4103801100
[E220/E220E]
411022655Y
[E215E]
4100255870
411020945P
411020945P
4105906400
[E220/E220E]
411020945P
[E220/E220E]
4110007330
4111167180
7-6
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 R401
#4 R402
#4 R403
R404
R406
1-227-370-11
1-227-370-11
1-260-298-51
Pending
1-243-478-11
RES-CHIP
1.82K
RES-CHIP
1.82K
CARBON (SMALL) 3.3
METAL OXIDE FILM 0.75
CARBON (SMALL) 1.5
1/10W 419A118212
1/10W 419A118212
1/2W 4050133955
1W 4171075856
1/4W 4050515955
#4 R407
R408
R409
R411
R412
1-260-322-51
Pending
Pending
1-242-988-11
1-242-988-11
CARBON (SMALL) 330
CARBON (SMALL) 3.3K
RES-CHIP
10K
METAL FILM 6.81K
METAL FILM 6.81K
1/2W 4050133155
1/2W 4050133254
1/10W 4010110202
1/4W 4257046811
1/4W 4257046811
#4
#4
#4
#4
#4
R500
R501
R502
R503
R504
1-247-798-11
1-216-083-11
1-227-372-11
1-216-065-11
1-227-379-11
CARBON (SMALL) 43
RES-CHIP
27K
RES-CHIP
22.1K
RES-CHIP
4.7K
RES-CHIP
732
1/4W 4050543055
1/10W 4010127352
1/10W 419A122122
1/10W 4010147252
1/10W 419A173202
#4
#4
#4
#4
R505
R506
R507
R508
R509
Pending
1-216-073-91
1-216-073-91
1-249-430-11
1-247-844-11
RES-CHIP
2.8K
RES-CHIP
10K
RES-CHIP
10K
CARBON (SMALL) 12K
CARBON (SMALL) 3.6K
1/10W 4010128202
1/10W 4010110352
1/10W 4010110352
1/4W 4050512355
1/4W 4050536255
#4
#4
#4
#4
R510
R511
R512
R513
R515
1-216-025-11
1-216-025-11
1-216-198-11
1-216-025-11
Pending
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1/10W 4010110152
1/10W 4010110152
1/8W 4010810252
1/10W 4010110152
1/10W 4010168302
#4
#4
#4
#4
R516
R517
R518
R519
R520
1-247-846-11
1-216-073-91
1-218-769-11
1-244-194-11
Pending
CARBON (SMALL) 4.3K
RES-CHIP
10K
RES-CHIP
510K
METAL OXIDE 100
METAL OXIDE FILM 0.22
1/4W 4050543255
1/10W 4010110352
1/10W 4010151452
2W 4172010156
1W 4171022856
R521
#4 R522
Pending
METAL FILM
1-216-065-11 RES-CHIP
22.6K
4.7K
#4 R522
1-216-041-11 RES-CHIP
470
#4 R523
#4 R524
#4 R525
1-216-073-91 RES-CHIP
10K
1-216-071-11 RES-CHIP
8.2K
1-243-482-11 CARBON (SMALL) 56
1/4W 4257042262
1/10W 4010147252
[E220/E220E]
1/10W 4010147152
[E215E]
1/10W 4010110352
1/10W 4010182252
1/4W 4050556055
#4 R526
#4 R527
R528
#4 R529
#4 R530
1-216-065-11
1-216-073-91
Pending
1-249-417-11
1-244-277-11
1/10W 4010147252
1/10W 4010110352
1/2W 4077B12155
1/4W 4050510255
3W 417731895A
#4 R531
1-216-055-11 RES-CHIP
1.8K
#4 R531
1-215-049-91 RES-CHIP
1K
#4 R532
R533
R534
1-260-312-51 CARBON (SMALL) 47
Pending
METAL OXIDE 1.3K
Pending
METAL OXIDE 10
1/10W 4010118252
[E220/E220E]
1/10W 4010110252
[E215E]
1/2W 4050147055
1W 4177113253
1W 4171010053
#4 R535
#4 R536
R537
#4 R538
#4 R539
1-249-417-11
1-216-069-11
Pending
1-216-065-11
1-216-073-91
1/4W 4050510255
1/10W 4010168252
1/4W 4050115355
1/10W 4010147252
1/10W 4010110352
RES-CHIP
4.7K
RES-CHIP
10K
METAL FILM 120
CARBON (SMALL) 1K
METAL OXIDE 1.8
CARBON (SMALL) 1K
RES-CHIP
6.8K
CARBON (SMALL) 15K
RES-CHIP
4.7K
RES-CHIP
10K
(d)
REF.NO. PART NO.
<RESISTOR>
100
100
1K
100
68K
CPD-E220/E220E/E215E
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
#4
#4
#4
#4
R540
R543
R544
R545
1-260-364-51
1-242-979-11
1-260-352-51
1-260-352-51
DESCRIPTION
CARBON (SMALL) 1M
METAL OXIDE 270
CARBON (SMALL) 100K
CARBON (SMALL) 100K
REMARK
1/2W
1W
1/2W
1/2W
4050110555
4177127153
4050110455
4050110455
[E220/E220E]
1/4W 4050547255
[E220/E220E]
#4 R547
1-249-425-11 CARBON (SMALL) 4.7K
#4 R549
1-216-073-91 RES-CHIP
10K
R551
R552
R553
#4 R554
Pending
Pending
Pending
1-216-154-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
100K
100K
15
#4 R555
#4 R556
R557
#4 R558
#4 R559
1-247-807-31
1-216-073-91
Pending
1-249-431-11
1-249-417-11
CARBON (SMALL) 100
RES-CHIP
10K
METAL OXIDE 10
CARBON (SMALL) 15K
CARBON (SMALL) 1K
1/4W 4050510155
1/10W 4010110352
1W 4171010053
1/4W 4050515355
1/4W 4050510255
#4
#4
#4
#4
#4
R560
R561
R562
R563
R565
1-216-101-11
1-249-437-11
1-216-073-91
1-249-437-11
1-215-049-91
RES-CHIP
150K
CARBON (SMALL) 47K
RES-CHIP
10K
CARBON (SMALL) 47K
RES-CHIP
1K
1/10W 4010115452
1/4W 4050547355
1/10W 4010110352
1/4W 4050547355
1/10W 4010110252
#4
#4
#4
#4
#4
R566
R567
R568
R569
R570
1-249-429-11
1-216-073-91
1-249-429-11
1-260-326-51
1-216-057-91
CARBON (SMALL) 10K
RES-CHIP
10K
CARBON (SMALL) 10K
CARBON (SMALL) 680
RES-CHIP
2.2K
1/4W 4050510355
1/10W 4010110352
1/4W 4050510355
1/2W 4050168155
1/10W 4010122252
#4
#4
#4
#4
#4
R571
R572
R573
R574
R575
1-249-425-11
1-249-393-11
1-247-868-91
1-216-095-11
1-216-662-11
CARBON (SMALL) 4.7K
CARBON (SMALL) 10
CARBON (SMALL) 36K
RES-CHIP
82K
RES-CHIP
3K
1/4W 4050547255
1/4W 4050510055
1/4W 4050536355
1/10W 4010182352
1/10W 4010130252
R576
R577
#4 R578
#4 R579
#4 R580
1-242-973-11
Pending
1-249-417-11
1-216-059-11
1-216-025-11
METAL OXIDE 30K
CARBON (SMALL) 68
CARBON (SMALL) 1K
RES-CHIP
2.7K
RES-CHIP
100
3W 4177330355
1/4W 4050568055
1/4W 4050510255
1/10W 4010127252
1/10W 4010110152
[E220/E220E]
#4 R580
1-216-041-11 RES-CHIP
R581
#4 R582
#4 R583
#4 R584
Pending
1-249-422-11
1-244-277-11
1-249-089-11
CARBON (SMALL) 33K
CARBON (SMALL) 2.7K
METAL OXIDE 1.8
RES-CHIP
47K
1/10W 4010147152
[E215E]
1/4W 4050533355
1/4W 4050527255
3W 417731895A
1/10W 4010147352
#4 R585
R586
R589
#4 R590
#4 R591
1-249-401-11
Pending
Pending
1-247-903-81
1-216-091-11
CARBON (SMALL) 47
METAL FILM 110K
METAL FILM 10K
CARBON (SMALL) 1M
RES-CHIP
56K
1/4W 4050547055
1/4W 4257041103
1/4W 4257041002
1/4W 4050510555
1/10W 4010156352
#4 R592
R594
#4 R595
R596
R597
1-216-089-11
Pending
1-216-065-11
Pending
Pending
RES-CHIP
RES-CHIP
RES-CHIP
1/10W 4010147352
1/10W 4010112452
1/10W 4010147252
1/10W 4010182302
1/2W 4050182055
#4 R598
1-215-049-91 RES-CHIP
7-7
470
47K
120K
4.7K
82K
CARBON (SMALL) 82
1K
1/10W 4010110352
[E220/E220E]
1/10W 4010110202
1/10W 4010110402
1/10W 4010110402
1/8W 4010815052
1/10W 4010110252
[E220/E220E]
CPD-E220/E220E/E215E
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
(d)
REF.NO. PART NO.
DESCRIPTION
REMARK
#4 R599 1-227-370-11
R601 0 1-260-132-11
R603
Pending
R605
Pending
RES-CHIP
1.82K
CARBON (SMALL) 560K
METAL OXIDE 30K
METAL OXIDE FILM 150K
1/10W 419A118212
1/2W 4050156455
2W 4172030353
1W 4171015456
#4
#4
#4
#4
#4
R609
R610
R611
R612
R614
1-249-422-11
1-216-001-11
1-249-396-11
1-227-377-11
1-216-361-11
CARBON (SMALL) 2.7K
RES-CHIP
10
CARBON (SMALL) 18
RES-CHIP
4.99K
METAL OXIDE 0.22
1/4W 4050527255
1/10W 4010110052
1/4W 4050518055
1/10W 419A149912
1/4W 4172022855
#4
#4
#4
#4
#4
R615
R616
R618
R619
R620
1-244-176-11
1-244-179-11
1-216-073-91
1-216-073-91
1-215-049-91
METAL FILM
METAL FILM
RES-CHIP
RES-CHIP
RES-CHIP
1.82K
3.92K
10K
10K
1K
1/4W 4257041821
1/4W 4257043921
1/10W 4010110352
1/10W 4010110352
1/10W 4010110252
#4
#4
#4
#4
#4
R621
R622
R623
R624
R625
1-216-182-11
1-216-182-11
1-216-025-11
1-216-072-11
1-216-073-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
220
220
100
1.9K
10K
1/8W 4010822152
1/8W 4010822152
1/10W 4010110152
1/10W 4010191252
1/10W 4010110352
#4 R626
R627
#4 R628
#4 R629
R630
1-216-077-11
Pending
1-247-802-11
1-249-417-11
Pending
RES-CHIP
15K
RES-CHIP
4.12K
CARBON (SMALL) 62
CARBON (SMALL) 1K
RES-CHIP
3.9K
1/10W 4010115352
1/10W 419A141212
1/4W 4050562055
1/4W 4050510255
1/10W 4010139252
R631
R632
#4 R640
#4 R641
#4 R642
Pending
Pending
1-249-429-11
1-249-413-11
1-249-409-11
RES-CHIP
10K
RES-CHIP
10K
CARBON (SMALL) 10K
CARBON (SMALL) 470
CARBON (SMALL) 220
1/10W 4010110202
1/10W 4010110202
1/4W 4050510355
1/4W 4050547155
1/4W 4050522155
R643
R644
#4 R648
#4 R651
R652
Pending
Pending
1-260-089-11
1-216-073-91
1-243-480-11
RES-CHIP
115K
RES-CHIP
2.8K
CARBON (SMALL) 150
RES-CHIP
10K
CARBON (SMALL) 300
1/10W 419A111532
1/10W 4010128202
1/2W 4050115155
1/10W 4010110352
1/4W 4050530155
R653
R655
#4 R656
#4 R658
#4 R659
1-215-888-11
Pending
1-249-429-11
1-249-429-11
1-249-417-11
METAL OXIDE 220
RES-CHIP
1.6K
CARBON (SMALL) 10K
CARBON (SMALL) 10K
CARBON (SMALL) 1K
2W 4172022155
1/10W 4010116252
1/4W 4050510355
1/4W 4050510355
1/4W 4050510255
#4
#4
#4
#4
R660
R661
R665
R666
R669
1-249-429-11
1-249-419-11
1-216-073-91
1-249-419-11
Pending
CARBON (SMALL) 10K
CARBON (SMALL) 1.5K
RES-CHIP
10K
CARBON (SMALL) 1.5K
CARBON (SMALL) 1
1/4W 4050510355
1/4W 4050515255
1/10W 4010110352
1/4W 4050515255
1/2W 4050110955
R670
#4 R672
#4 R673
#4 R675
R676
Pending
1-216-128-11
1-216-089-11
1-244-185-11
Pending
CARBON (SMALL) 1.5M
RES-CHIP
2M
RES-CHIP
47K
METAL FILM 107K
RES-CHIP
0
1/4W 4050515555
1/10W 4010120552
1/10W 4010147352
1/4W 4257041073
1/8W 4010800052
#4 R677
R678
#4 R902
#4 R903
R904
1-216-121-11
Pending
1-249-417-11
1-249-417-11
1-247-807-31
RES-CHIP
1M
CARBON (SMALL) 2M
CARBON (SMALL) 1K
CARBON (SMALL) 1K
CARBON (SMALL) 100
1/10W 4010110552
1/4W 4050520555
1/4W 4050510255
1/4W 4050510255
1/4W 4050510155
#4 R905
#4 R906
1-249-417-11 CARBON (SMALL) 1K
1-249-417-11 CARBON (SMALL) 1K
1/4W 4050510255
1/4W 4050510255
REF.NO. PART NO.
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
DESCRIPTION
REMARK
#4 R907
#4 R908
#4 R909
1-249-417-11 CARBON (SMALL) 1K
1-216-073-91 RES-CHIP
10K
1-249-417-11 CARBON (SMALL) 1K
1/4W 4050510255
1/10W 4010110352
1/4W 4050510255
#4
#4
#4
#4
#4
1-216-073-91
1-249-417-11
1-216-222-91
1-249-417-11
1-244-247-11
1/10W 4010110352
1/4W 4050510255
1/8W 4010810352
1/4W 4050510255
1/4W 4257043329
R910
R911
R912
R913
R914
RES-CHIP
10K
CARBON (SMALL) 1K
RES-CHIP
10K
CARBON (SMALL) 1K
METAL FILM 33.2
#4 R915
#4 R918
#4 R919
1-240-907-11 METAL FILM 30.1K
1-216-073-91 RES-CHIP
10K
1-249-425-11 CARBON (SMALL) 4.7K
#4 R920
1-216-073-91 RES-CHIP
10K
#4 R921
1-215-049-91 RES-CHIP
1K
#4
#4
#4
#4
#4
R922
R923
R924
R925
R926
1-216-073-91
1-216-073-91
1-215-049-91
1-249-429-11
1-216-025-11
RES-CHIP
10K
RES-CHIP
10K
RES-CHIP
1K
CARBON (SMALL) 10K
RES-CHIP
100
1/10W 4010110352
1/10W 4010110352
1/10W 4010110252
1/4W 4050510355
1/10W 4010110152
#4
#4
#4
#4
#4
R927
R928
R929
R930
R931
1-216-065-11
1-216-073-91
1-216-222-91
1-216-222-91
1-216-222-91
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
10K
10K
10K
10K
1/10W 4010147252
1/10W 4010110352
1/8W 4010810352
1/8W 4010810352
1/8W 4010810352
#4
#4
#4
#4
#4
R932
R933
R934
R935
R936
1-249-397-11
1-249-397-11
1-249-401-11
1-216-222-91
1-216-121-11
CARBON (SMALL) 22
CARBON (SMALL) 22
CARBON (SMALL) 47
RES-CHIP
10K
RES-CHIP
1M
1/4W 4050522055
1/4W 4050522055
1/4W 4050547055
1/8W 4010810352
1/10W 4010110552
#4
#4
#4
#4
#4
R937
R938
R939
R940
R941
1-216-017-11
1-216-222-91
1-216-222-91
1-216-073-91
1-216-174-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47
10K
10K
10K
100
1/10W 4010147052
1/8W 4010810352
1/8W 4010810352
1/10W 4010110352
1/8W 4010810152
#4 R942
#4 R943
R944
#4 R945
#4 R946
1-216-174-11
1-247-807-31
Pending
1-216-017-11
1-216-174-11
RES-CHIP
100
CARBON (SMALL) 100
RES-CHIP
470
RES-CHIP
47
RES-CHIP
100
1/8W 4010810152
1/4W 4050510155
1/8W 4010847152
1/10W 4010147052
1/8W 4010810152
R948
R949
#4 R950
R951
#4 R952
Pending
Pending
1-218-769-11
Pending
1-216-017-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1/10W 4010114202
1/10W 4010151352
1/10W 4010151452
1/10W 4010128302
1/10W 4010147052
R954
#4 R955
#4 R959
Pending
RES-CHIP
10K
1-249-429-11 CARBON (SMALL) 10K
RES-CHIP
0
1.4
51K
510K
28K
47
1/4W 4257043012
1/10W 4010110352
1/4W 4050547255
[E220/E220E]
1/10W 4010110352
[E220/E220E]
1/10W 4010110252
#4 R5001 1-244-194-11 METAL OXIDE 100
#4 R5003 1-249-429-11 CARBON (SMALL) 10K
1/10W 4010110202
1/4W 4050510355
1/10W 4010100052
[E215E]
2W 4172010156
1/4W 4050510355
#4
#4
#4
#4
#4
1/10W 4010113352
1/10W 4010110352
1/2W 4050110355
1/4W 4050547155
1/4W 4050510355
7-8
R5102
R5103
R5104
R5106
R5107
1-216-075-11
1-216-073-91
1-260-340-51
1-249-413-11
1-249-429-11
RES-CHIP
120K
RES-CHIP
10K
CARBON (SMALL) 10K
CARBON (SMALL) 470
CARBON (SMALL) 10K
The components identified by mark ¡
are critical for safety.
Replace only with part number specified.
REF.NO. PART NO.
R5108
R5109
R5110
R5111
R5112
Pending
1-216-121-11
1-216-041-11
1-216-684-11
1-216-069-11
DESCRIPTION
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
REMARK
(d)(h)
REF.NO. PART NO.
18K
1M
470
20K
6.8K
1/10W 4010118302
1/10W 4010110552
1/10W 4010147152
1/10W 4010120352
1/10W 4010168252
R5113
Pending
RES-CHIP
51K
R5114
Pending
RES-CHIP
120K
#4 R5115 1-216-352-51 CARBON (SMALL) 100K
#4 R5116 1-216-352-51 CARBON (SMALL) 100K
R5117 1-247-807-31 CARBON (SMALL) 100
1/10W 4010151352
1/10W 4010112452
1/2W 4050110455
1/2W 4050110455
1/4W 4050510155
#4
#4
#4
#4
#4
RES-CHIP
10K
CARBON (SMALL) 4.7K
RES-CHIP
26.7K
CARBON (SMALL) 10K
RES-CHIP
60.4K
1/10W 4010110352
1/4W 4050547255
1/10W 419A126722
1/4W 4050510355
1/10W 419A160422
R5123
Pending
RES-CHIP
10K
R5124 1-247-807-31 CARBON (SMALL) 100
CARBON (SMALL) 430
R5125
Pending
R5126
Pending
RES-CHIP
1.47K
CARBON (SMALL) 20
R5127
Pending
1/10W 4010110202
1/4W 4050510155
1/4W 4050543155
1/10W 419A114712
1/2W 4050120055
CARBON (SMALL) 36
RES-CHIP
1K
RES-CHIP
10K
RES-CHIP
820K
RES-CHIP
47K
1/2W 4050136055
1/10W 4010110252
1/10W 4010110352
1/8W 4010882452
1/10W 4010147352
METAL OXIDE FILM 4.7
1W
#4
#4
#4
#4
CPD-E220/E220E/E215E
Les composants identifiés par une
marque ¡ sont critiques pour la sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
DESCRIPTION
REMARK
<VARIABLE RESISTOR>
VR5010
Pending
RES, ADJ, CERMET 50K (HV ADJ)
5.22E+11
<CRYSTAL>
X901
1-781-719-11 VIBRATOR, CRYSTAL (24MHz)
7152400010
******************************************************************************************
#4
#4
#4
#4
R5118
R5119
R5120
R5121
R5122
1-216-073-91
1-249-425-11
1-244-295-11
1-249-429-11
1-244-299-11
R5128
R5129
R5130
R5131
R5132
Pending
1-215-049-91
1-216-073-91
1-216-268-11
1-216-089-11
R5134
Pending
H BOARD, COMPLETE
****************************
<CAPACITOR>
C701
C702
1-135-360-11 CERAMIC
1-135-360-11 CERAMIC
1000pF
1000pF
7181102552
7181102552
<LED>
#4 LED7011-517-965-11 DIODE LT5J62-23-D63 (POWER)
412065J620
<RESISTOR>
4171247956
#4 R701
R702
#4 R705
#4 R706
#4 R709
<RELAY>
RY501 1-755-423-11 RELAY
#4 RY60101-775-031-11 RELAY
4420412016
4420612014
1-244-177-11
Pending
1-244-180-11
1-244-178-11
1-244-181-11
METAL FILM
METAL FILM
METAL FILM
METAL FILM
METAL FILM
2.15K
10.2K
6.19K
3.83K
17.4K
4257042151
4257041022
4257046191
4257043831
4257041742
<SWITCH>
<SWITCH>
SW701 1-771-734-11 SWITCH, TACTILE (MENU)
S602 1-771-757-11 SWITCH, POWER PUSH
SW901 1-771-930-11 SWITCH, KEY BOARD (RESET)
4410606000
4410204018
4410604034
******************************************************************************************
<SPARK GAP>
SG501 1-519-422-21 GAP, SPARK
5106152204
<TRANSFORMER>
T501 0 1-453-358-11
#4 T502 1-435-846-11
#4 T503 1-435-845-11
T504 1-435-844-11
#4 T601 0 1-435-853-11
TRANSFORMER, FLYBACK
TRANSFORMER, DRIVER
7050307C2U
7050207C2U
7050907C2U
TRANSFORMER, FOCUS
7050507C2U
PFC X’FORMER
7051309R00
[E220 [NH]/E220E/E215E]
#4 T603 0 1-435-843-11 TRANSFORMER, POWER
7050107C2U
<THERMISTOR>
TH60101-803-533-11 THERMISTOR
TH60201-803-963-11 THERMISTOR
710501003B
7106070027
7-9
Related documents
CPD-E220/E215E/E220E - Wiki Karat
CPD-E220/E215E/E220E - Wiki Karat
HMD-A400
HMD-A400
Service Manual MCD
Service Manual MCD
Sanyo VM-6615P User's Manual
Sanyo VM-6615P User's Manual
truXTRAC FFPE DNA 8 microTUBE Strip Kit for chemagen
truXTRAC FFPE DNA 8 microTUBE Strip Kit for chemagen
Les méthodes alternatives en expérimentation animale
Les méthodes alternatives en expérimentation animale
truXTRAC FFPE RNA Kit
truXTRAC FFPE RNA Kit
Trinitron Color Computer Display
Trinitron Color Computer Display
Les méthodes alternatives en expérimentation
Les méthodes alternatives en expérimentation
truXTRAC™ FFPE DNA microTUBE Kit for chemagen
truXTRAC™ FFPE DNA microTUBE Kit for chemagen