Download ViewSonic VA702mb Service manual
Transcript
Service Manual ViewSonic VA502mb-1 Model No. VS11352 15” Color TFT LCD Display (VA502mb-1_SM Rev. 1a Dec. 2006) ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583 Copyright Copyright © 2006 by ViewSonic Corporation. All rights reserved. No part of this publication may be reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language or computer language, in any form or by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without the prior written permission of ViewSonic Corporation. Disclaimer ViewSonic makes no representations or warranties, either expressed or implied, with respect to the contents hereof and specifically disclaims any warranty of merchantability or fitness for any particular purpose. Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes. Trademarks Optiquest is a registered trademark of ViewSonic Corporation. ViewSonic is a registered trademark of ViewSonic Corporation. All other trademarks used within this document are the property of their respective owners. Revision History Revision SM Editing Date 1a 12/20/2006 ECR Number Description of Changes Initial Release Editor Jamie Chang i ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 TABLE OF CONTENTS 1. Precautions and Safety Notices 1 2. Specification 4 3. Front Panel Function Control Description 6 4. Circuit Description 8 5. Adjustment Procedure 19 6. Troubleshooting Flow Chart 39 7. Block Diagram 40 8. Schematic Diagrams 41 9. PCB Layout Diagrams 50 10. Exploded Diagram and Exploded Parts List 56 11. Recommended Spare Parts List 60 ii ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 1. Precautions and Safety Notices 1.1 SAFETY PRECAUTIONS This monitor is manufactured and tested on a ground principle that a user’s safety comes first. However, improper use or installation may cause damage to the monitor as well as the user. Carefully go over the following WARNINGS before installing and keep this guide handy. WARNINGS - This monitor should be operated only at the correct power sources indicated on the label on the rear end of the monitor. If you’re unsure of the power supply in your residence, consult you local dealer or power company. - Use only the special power adapter that comes with this monitor for power input. Do not try to repair the monitor your self as it contains no userserviceable parts. This monitor should only be repaired by a qualified technician. - Do not remove the monitor cabinet. There is highvoltage parts inside that may cause electric shock to human bodies, even when the power cord is unplugged. - Stop using the monitor if the cabinet is damaged. Have it checked by a service technician. Put your monitor only in a clean, dry environment. If it gets wet, unplug the power cable immediately and consult your service technician. - Always unplug the monitor before cleaning it .Clean the cabinet with a clean, dry cloth. Apply nonammonia based cleaner onto the cloth, not directly onto the glass screen. - Keep the monitor away from magnetic objects, motors, TV sets, and transformer. Do not place heavy objects on the monitor or power cord. 1.2 PRODUCT SAFETY NOTICE Many electrical and mechanical parts in this chassis have special safety visual inspections and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltages, wattage, etc. Before replacing any of these components read the parts list in this manual carefully. The use of substitute replacement parts which do not have the same safety characteristics as specified in the parts list may create shock, fire ,or other hazards. 1.3 SERVICE NOTES When replacing parts or circuit boards, clamp the lead wires around terminals before soldering. When replacing a high wattage resistor(more than 1W of metal oxide film resistor) in circuit board, keep the resistor about 5mm away from circuit board. Keep wires away from high voltage, high temperature components and sharp edges. Keep wires in their original position so as to reduce interference. Usage of this product please refer to also user’s manual. 1 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 1.4 HANDING AND PLACING METHODS Correct Methods: Incorrect Methods: Only touch the metal frame of the LCD panel or the front cover of the monitor. Do not touch the surface of the polarizer. Surface of the LCD panel is pressed by fingers and that may cause “Mura.” Take out the monitor with cushions Taking out the monitor by grasping the LCD panel. That may cause “Mura.” Place the monitor on a clean and soft foam pad. Placing the monitor on foreign objects. That could scratch the surface of the panel or cause “Mura.” 2 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Place the monitor on the lap, the panel surface The panel is placed facedown on the lap. That must be upwards. may cause “Mura.” 3 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 2. Specification 2.1 PRODUCT SPECIFICATIONS INTRODUCTION 1st TFT LCD panel Input Signal Sync Compatibility Compatibility Power Voltage Power Consumption FEATURES Size Luminance (Typ) Contrast Ratio (Typ) Colors Response Time (Typ) Viewing Angle (H/V) (Typ) Recommend resolution Analog (75ohms, 0.7/1.0 Vp-p) Digital (DVI-D) Separate Sync Composite Sync Sync on Green PC Power Mac TV Box (NextVision 6) AC 100-240V, 50/60Hz On Mode(Max / Typ) Active Off Mode (Max) Ergonomics Tilt ( -5 ° - 22.5 °) Swivel Pivot Height Adjust OSD Control [ 1 ] [ 2 ] [ ][▲] [▼] Dimension Weight Operating Condition Storage Condition Regulation VA502mb 15 “ 250 cd/㎡ 450 :1 16.2 M colors (6+2bit panel) 16 ms 120° / 100 ° 1024x768 @60Hz Yes No Yes No No Yes Yes no Yes Under30 W in max Saving mode< 4W Off mode <2 W Yes No No No Yes Physical (W x H x D) Package (W x H x D) Physical (Net Weight) Package (Gross Weight) Temperature (℉/℃) Humidity (%) Temperature (℉/℃) Humidity (%) 344.6x336.5 x 160 mm 408x414 x 314 mm 3.0Kg 4.2 Kg 41℉~95℉ / 5℃~35℃ 10 % - 85 % -4℉~140℉ / -20℃~60℃ 5 % - 85 % UL, cUL, TUV/GS, TUV/ERGO (cover ISO13406-2), 4 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 PRODUCT DEFINITION AND SPECIFICATION Product Name VA502mb Model Number VS11352 Region M model for America OSD Languages English, Spanish, Portuguese TFT LCD Panel and Model # SAV Model # :150XG04TB Scalar Novatech Model# NT68521A-XFG Input Signal Analog Sync Compatibility Separate Adapter No Power Cable Refer to Appendix D Analog Cable (1.8m, color : black), with PC Yes 2001 and Hot Plug Detect &DDC Audio Cable (1.8m, Color: black) with PC 2001 Yes ViewSonic CD Wizard English, Spanish, Portuguese, ViewSonic Quick Start Guide Screen Protector Mylar Hi Pot label QA pass label Hg Warnning label Warranty Sticker Warranty Card Carton Sticker PE bag of Carton TFT LCD PANEL 1st Panel Source Type Active Size Pixel Arrangement Pixel Pitch Glass Treatment # of Backlights Backlight Life Luminance –Condition: CT = 6500 K Contrast = Max, Brightness = Max Brightness Uniformity Contrast Ratio Color Depth Vertical) Viewing Angle (Horizontal) Viewing Angle (Vertical) Response Time 10%-90% @ Ta=25°C Panel Defects Yes Yes Yes Yes NO NO NO NO SVA 150XG04TB TN, LVDS 304.128 mm (H) x 228.096mm (V) RGB Vertical Stripe 0.297 mm Anti Glare (Hard coating 3H) 2 CCFL edge-light 30,000 Hours (Min) 250cd/m2 (Typ after 30 minute warm up) 1.3 (max) 450:1 (Typ), 350:1 (Min) 16.2 million colors (6+2 bit panel) 120 deg (Typ)@ CR>10 100 deg (Typ) @ CR>10 16 ms (Tr= 12ms, Tf = 4 ms) (Typ) 25 ms (Tr= 18ms, Tf = 7 ms) (Max) Please see Panel Quality Specifications. 5 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 3. Front Panel Function Control Description Do the following to adjust the display setting: 6 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 7 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 4. Circuit Description 4.1 LCD MONITOR DESCRIPTION The LCD MONITOR will contain a Main Board, a Power Board, Key Board and Audio board which house the flat panel control logic, brightness control logic and DDC. Monitor Block Diagram CCFL Drive. Flat Panel and CCFL backlight Power Board (Include: adapter, inverter) RS232 Connector For white balance adjustment in factory mode Main Board Video signal, DDC Audio Board Key Board AC-IN 100V-240V HOST Computer 4.2 MAIN BOARD BLOCK FUNCTION DESCRIPTION The main board contains panel control logic, brightness control logic; DDC and DC convert DC circuit and so on. Power board R G B H V SDA SCL MST8011B Backlight and Panel OSC EPROM Audio board EPROM Key board 8 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 4.3 PWPC BOARD BLOCK FUNCTION DESCRIPTION PWPC board combines to adapter and inverter, Adapter which commonly consists of bridge rectifier and filter, start circuit, PWM control circuit, protection circuits and convert to 12V, 5V DC voltage by input 90V-240V AC voltage that provide power supply for each chips in the main board and inverter. Inverter is DC TO AC circuit. It changes the 12v DC of power supply to about 600-800v AC that drives the backlight. It mostly consists of starting circuit, PWM controller, DC changing circuit, LC surging circuit, output circuit and protection circuit etc. AC input Bridge Rectifier and Filter EMI filter Rectifier CMOS Transformer Start Circuit R906, R907 CN102 5V PWM Control OSC and Output Circuit Lamp Feedback Circuit Over Voltage Protect 12V ON/OFF MOSFET Q203 DC Convert Circuit Over Voltage PWM Control ON/OFF Control DIM 4.4 INTRODUCTION OF IC MST8011B (U401): integrate ADC, OSD, SCALER, LVDS, convert analog RGB into digital and room and shrink scaling output to LCD panel. PIN Function: 9 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 10 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 11 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 AIC1084-33PM (U202): DC power convert, used to 5v convert 3.3v. RT9164-25PL (U201): DC power convert, used to 5v convert 2.5v. W78E065A40PL (U601): The W78E65 is an 8-bit microcontroller which has an in-system programmable Flash EPROM for firmware updating. The instruction set of the W78E65 is fully compatible with the standard 8052. The W78E65 contains a 64K bytes of main ROM and a 4K bytes of auxiliary ROM which allows the contents of the 64KB main ROM to be updated by the loader program located at the 4KB auxiliary ROM; 256+1K bytes of on-chip RAM; four 8-bit bi-directional and bit-addressable I/O ports; an additional 4-bit port P4; three 16-bit timer/counters; a serial port. These peripherals are supported by a eight sources two-level interrupt capability. To facilitate programming and verification, the ROM inside the W78E65 allows the program memory to be programmed and read electronically. Once the code is confirmed, the user can protect the code for security. The W78E65 microcontroller has two power reduction modes, idle mode and power-down mode, both of which are software selectable. The idle mode turns off the processor clock but allows for continued peripheral operation. The power-down mode stops the crystal oscillator for minimum power consumption. The external clock can be stopped at any time and in any state without affecting the processor. 12 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 PIN Descriptions: 13 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Circuit Diagram P1.0 Port 1 Port 1 Latch P1.7 ACC B P0.0 Port 0 Interrupt T1 Latch T2 P0.7 Timer 2 Timer 0 Port 0 DPTR Temp Reg. Stack Pointer PSW ALU PC Timer 1 Incrementor UART Addr. Reg. P3.0 Port 3 64KB Port 3 SFR RAM Address Instruction Decoder & Sequencer Latch P3.7 Flash E ROM 4KB Flash EROM 256+1K bytes RAM & SFR P2.0 Port 2 Latch Bus & Clock Controller P4.0 P4.7 Port 4 Port 2 P2.7 Port 4 Latch Reset Block Oscillator XTAL1 XTAL2 ALE RST PSEN Power control VCC Vss TDA7496(U201): The TDA7496L is a stereo 2W+2W class AB power amplifier assembled in the @ Powerdip 14+3+3 package, specially designed for high quality sound, TV and Monitor applications. Features of the TDA7496L include linear volume control, Stand-by and mute functions. The function of each pin and the inside circuit diagram are as follows: 14 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Block Diagram PIN Function 15 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 LD7552BPN (IC901): The LD7552B are low cost, low startup current, current mode PWM controllers with green-mode power- saving operation. The integrated functions include the leading-edge blanking of the current sensing, internal slope compensation. They provide the users a superior AC/DC power application of higher efficiency, low external component counts, and lower cost solution. Furthermore, LD7552B feature more protections like OLP (Over Load Protection) and OVP (Over Voltage Protection) to eliminate the external protection circuits. It is designed for the switching adaptor with 30W~60W output, offered in both SOP-8 and DIP-8 package. The function of each pin and the inside circuit diagram are as follows: PIN Descriptions: 16 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Block Diagram BA9741F (U201): The BA9741F is a timer latch, short-circuit protection circuit is built in. Circuit to prevent malfunction during low input voltage is built in. Built-in reference voltage(2.5v)circuit with output pin. Dead time over the whole range of possible to adjust half period of whole duty range. Recommendable for regulator in camcorder. The function of each pin and the circuit diagram inside are as follows: 17 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 PIN Descriptions: Pin Names Function 1 CT External timing capacitance 2 RT External timing resistance 3 NON1 Positive input for error amplifier 1 4 INV1 Negative input for error amplifier 1 5 FB1 Output for error amplifier 1 6 DT1 Output 1 dead time/soft start setting 7 OUT1 Output 1 8 GND Ground 9 Vcc Power Supply 10 OUT2 Output 2 11 DT2 Output 2 dead time/soft start setting 12 FB2 Output for error amplifier 2 13 INV2 Negative input for error amplifier 2 14 NON2 Positive input for error amplifier 2 15 SCP Timing latch setting 16 VREF Reference voltage(2.5v) output Block Diagram 18 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 5. Adjustment Procedure 5.1 ADJUSTMENT CONDITIONS AND PRECAUTIONS 1. Approximately 30 minutes should be allowed for warm up before proceeding. 2. Adjustments should be undertaken only on those necessary elements since most of them have been carefully preset at the factory. 3. ESD protection is needed before adjustment. 5.2 MAIN ADJUSTMENTS NO. FUNCTIONS 1. White Balance 2. Geometry DESIGNATION Function Key Function Key 5.3 ALIGNMENT PROCEDURES Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment. 1. Adjust of White Balance 1.)How to do the Chroma-7120 MEM .Channel setting A. Reference to chroma 7120 user guide B. Use “ SC” key and “ NEXT” key to modify xyY value and use “ID” key to modify the TEXT description Following is the procedure to do white-balance adjust 2.)Setting the color temp. You want A. MEM.CHANNEL9 ( 9300 color): 9300 color temp. parameter is Wx = 0.283 ±0.03;Wy = 0.298 ±0.03; Y = 200 ±20 cd/m2 , B. MEM.CHANNEL10 ( 6500 color): 6500 color temp. parameter is Wx = 0.313±0.03;Wy = 0.329 ±0.03; Y = 200 ±20 cd/m2, C. MEM.CHANNEL10 ( SRGB color): 6500 color temp. parameter is Wx = 0.313±0.03;Wy = 0.329 ±0.03; Y = 200 ±20 cd/m2, 19 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 3.) Into factory mode of VA502mb Turn on power, press the MENU button, pull out the power cord, and then plug the power cord. Then the factory OSD will be at the left top of the panel. 4.) Bias adjustment: Set the Contrast to 70 Adjust the Brightness to 100. 5.) Gain adjustment: Move cursor to “-F-” and press MENU key A. Adjust 9300 color-temperature (1). Switch the Chroma-7120 to RGB-Mode (with press “MODE” button ) (2). Switch the MEM. channel to Channel 9 ( with up or down arrow on chroma 7120 ) (3). The LCD-indicator on chroma 7120 will show x = 0.283 ±0.03, y =0.298 ±0.03,Y = 200 ± 20 cd/m2 (4). Adjust the RED of color1 on factory window until chroma 7120 indicator reached the value R=100 (5). Adjust the GREEN of color1 on factory window until chroma 7120 indicator reached the value G=100 (6). Adjust the BLUE of color1 on factory window until chroma 7120 indicator reached the value B=100 (7). Repeat above procedure ( item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 B. Adjust 6500 color-temperature (1). Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2). Switch the MEM .channel to Channel 10( with up or down arrow on chroma 7120 ) (3). The LCD-indicator on chroma 7120 will show x = 0.313 ±0.03, y = 0.329 ±0.03, Y = 200 ± 20 cd/m2 (4). Adjust the RED of color3 on factory window until chroma 7120 indicator reached the value R=100 (5). Adjust the GREEN of color3 on factory window until chroma 7120 indicator reached the value G=100 (6). Adjust the BLUE of color3 on factory window until chroma 7120 indicator reached the value B=100 (7). Repeat above procedure ( item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 20 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 C. Adjust SRGB color-temperature (1). Switch the chroma-7120 to RGB-Mode (with press “MODE” button ) (2). Switch the MEM .channel to Channel 10( with up or down arrow on chroma 7120 ) (3). The LCD-indicator on chroma 7120 will show x = 0.313 ±0.03, y = 0.329 ±0.03, Y = 200 ± 20 cd/m2 (4). Adjust the RED of color3 on factory window until chroma 7120 indicator reached the value R=100 (5). Adjust the GREEN of color3 on factory window until chroma 7120 indicator reached the value G=100 (6). Adjust the BLUE of color3 on factory window until chroma 7120 indicator reached the value B=100 (7). Repeat above procedure ( item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 E. Press reset key and Turn the Power-button “off to on” to quit from factory mode. 2. Geometry 1).Set cross-hatch pattern and preset timing as timing table listed. 2).Change to each mode in turn and wait for the monitor finish auto-alignment and save press before change to next mode. 3).Until all of modes are adjusted, exit OSD menu and press POWER OFF to exit factory mode. 5.4 Factory Defaults Item Defaults Item Defaults Contrast 70% Volume 50% (For VA702mb only) Brightness 100% Balance N/A Color Temperature 6500K Treble N/A Sharpness 0% Bass N/A OSD H. Position 50% 720x400/640x400 720x400 OSD V. Position 50% 640x480@60Hz 720x480@60Hz 640x480@60Hz OSD Time Out 15 Sec In SOG and Composite, 720x480@60Hz 640x480@60Hz N/A OSD Background Enabled In SOG and Composite, 1152x864@75Hz 1152x870@75Hz N/A Resolution Notice Enabled In SOG and Composite, 1280x768@60/75/85Hz 1024x768@60/75/85Hz N/A 21 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 5.5 Function Test 1 Product: 17” LCD Monitor 2 Test Equipment: Color Video Signal & Pattern (or PC with SXGA resolution and a sound card) 3 Test Condition: Before function test and alignment, each LCD Monitor should be warmed up for at least 30 minutes with the following conditions: (a)In room temperature, (b) With full-white screen, RGB, and Black (c) With cycled display modes, 640*480 (H=43.27kHz, V=85Hz) 800*600 (H=53.7kHz, V=85Hz) 1024*768 (H=68.67kHz, V=85Hz) 1280*1024 (H=79.97kHz, V=75Hz) 4 Test Display Modes & Pattern Compatible Modes Item Timing Analog 1 640 x 350 @ 70Hz, 31.5kHz Yes 2 640 x 480 @ 50Hz Yes 3 640 x 480 @ 60Hz, 31.5kHz Yes 4 640 x 480 @ 67Hz, 35.0kHz Yes 5 640 x 480 @ 72Hz, 37.9kHz Yes 6 640 x 480 @ 75Hz, 37.5kHz Yes 7 640 x 480 @ 85Hz, 43.27kHz Yes 8 720 x 400 @ 70Hz, 31.5kHz Yes 9 800 x 600 @ 56Hz, 35.1kHz Yes 10 800 x 600 @ 60Hz, 37.9kHz Yes 11 800 x 600 @ 72Hz, 48.1kHz Yes 12 800 x 600 @ 75Hz, 46.9kHz Yes 13 800 x 600 @ 85Hz, 53.7kHz Yes 14 832 x 624 @ 75Hz, 49.7kHz Yes 15 1024 x 768 @ 60Hz, 48.4kHz Yes 16 1024 x 768 @ 70Hz, 56.5kHz Yes 17 1024 x 768 @ 72Hz, 58.1kHz Yes 18 1024 x 768 @ 75Hz, 60.0kHz Yes 19 1024 x 768 @ 85Hz Yes 20 1152 x 864 @ 75Hz Yes 21 1152 x 870 @ 75Hz Yes 22 1280 x 720 @ 60Hz Yes 23 1280 x 960 @ 60Hz Yes 24 1280 x 960 @75Hz Yes 25 1280 x 1024 @ 60Hz Yes 26 1280 x 1024 @ 75Hz Yes 22 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Function Test Display Pattern Item Test Content Pattern Specification Remark 1 Frequency & Tracking Fine Line Moire Eliminate visual wavy noise. Figure 1 2 Contrast/Brigh tness 16 Gray Scale 16 gray levels sh should be distinguishable. Figure 2 3 Boundary Horizontal&Vertical Thickness Horizontal and Vertical position of video should be adjustable to be within the screen frame. Figure 3 4 RGB Color Performance RGB Color Intensities Contrast of each R, G, B, color should be normal. Figure 4,5,6 5 Screen Uniformity & Flicker Full White Should be compliant with the spec. Figure 7 6 Dead Pixel/Line White Screen & Dark Screen The numbers of dead pixels should be compliant with the spec. Figure 7,8 White & Black Pattern The screen must have the pure white and black pattern, no other color. Figure 9 7 White Balance 23 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Fine Line Morie Pattern (Figure1) Gray Scale Pattern (Figure2) Horizontal & Vertical Thickness Pattern (Figure 3) G. Color Pattern (Figure 5 R. Color Pattern (Figure 4) B. Color Pattern (Figure 6) 24 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Full White Pattern (Figure 7) Dark Screen Pattern (Figure 8) Black-White Pattern (Figure 9) 4.3 Function Test and Alignment Procedure All Modes Reset You should do “All Mode Reset” (Refer to Chapter III-3. Hot Keys for Function Controls) first. This action will allow you to erase all end-user’s settings and restore the factory defaults. Auto Image Adjust Please select and enter “Auto Image Adjust” function on Main Menu to see if it is workable. The “Auto Image Adjust” function is aimed to offer a better screen quality by built-in ASIC. For optimum screen quality, the user has to adjust each function manually. Firmware Test Pattern: Burn In Mode (Refer to Chapter III-3. Hot Keys for Function Controls) - Make sure the F/W is the latest version. DDC Test Pattern: EDID program Make sure it can pass test program. 25 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Fine Tune and Sharpness Test Signal: 1280*1024@60Hz Test Pattern: Line Moire Pattern Check and see if the image has noise and focus performs well. Eliminate visual line bar. If not, readjust by the following steps: (a)Select and enter “Fine Tune” function on “Manual Image Adjust” to adjust the image to eliminate visual wavy noise. (b)Then, select and enter “Sharpness” function to adjust the clarity and focus of the screen image. Boundary Test Signal: 1280*1024@60Hz Test Pattern: Horizontal & Vertical Line Thickness Pattern Check and see if the image boundary is within the screen frame. If not, readjust by the following steps: (a)Select and enter “Manual Image Adjust” function on OSD Main Menu. (b)Then, select and enter “Horizontal Size” or “Horizontal/Vertical Position” function to adjust the video boundary to be full scanned and within screen frame. White Balance Test Signal: 640*480@60Hz Test Pattern: White and Black Pattern 1.5.8 R, G, B, Colors Contrast Test Signal: 1280*1024@60Hz Test Pattern: R, G, B, Color Intensities Pattern and 16 Gray Scale Pattern - Check and see if each color is normal and distinguishable. If not, please return the unit to repair area. Screen Uniformity and Flicker Test Signal: 1280*1024@60Hz Test Pattern: Full White Pattern - Check and see if it is in normal condition. 1.5.10 Dead Pixel and Line Test Signal: 1280*1024@60Hz Test Pattern: Dark and White Screen Pattern - Check and see if there are dead pixels on LCD panel with shadow gauge and filter film. The total numbers and distance of dead pixels should be compliant with the spec. Mura Test Pattern: White, RGB, Black, & Grey Test Tool: 10% ND Filter - Check if the Mura can pass 10% ND Filter. 26 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Audio Test Signal: Voice signal (optional, depend on model) Test Pattern: liberty - Make sure there is audio output. Make sure that audio function (volume 80%) is working without noise and resonance. Make sure that the sound of right and left speakers are in balance. Check for Secondary Display Modes Test Signal: Analog: 640*350@70Hz; 640*480@60/67/72/75/85Hz; 720*400@70Hz; 800*600@56/60/72/75/85Hz; 832*624@75Hz, 1024*768@60/70/72/75/85Hz; 1280*1024@60/75Hz - Normally when the primary mode 1280*1024@60Hz is well adjusted and compliant with the specification, the secondary display modes will also be compliant with the spec. But we still have to check with the general test pattern to make sure every secondary is compliant with the specification. All Modes Reset After final QC step, we have to erase all saved changes again and restore the factory defaults. You should do “All Mode Reset” again. Power Off Monitor Turn off the monitor by pressing “Power” button. 27 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 5.6 Firmware Upgrade Procedure When you receive the returned monitor, please check whether the firmware version is the latest. If not, please do the following procedures to upgrade it to the latest version. 1 Equipment Needed - VA502mb/VA702mb Monitor - Fixture for Firmware Upgrade - Power Adapter (P/N: 47.58201.001) *1 for Fixture - VGA Cable (P/N: 42.59901.003) *1(Pin 4, 11 should be connected to GND) - PC (Personal Computer) - LPT Cable (P/N: 42.59906.001) *1 - Firmware Upgrade Program - One additional monitor for checking the program execution 28 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 2 Setup Procedure 2.1 Connect P2 of Fixture with printer port of PC by LPT Cable. 2.2 Connect P1 of Fixture with VA502mb/VA702mb Monitor by VGA Cable. 2.3 Plug Power Adapter to Fixture. 2.4 Connect Power Cord to VA502m/VA702mb Monitor. 2.5 Connect P3 to the Signal Generator (eg.Chroma2326) for verifying it after the operation being completed. 2.6 Connect PC to the additional monitor. JP1:to Power Adapter P1:to VGA Cable P3:to Signal Generator P2:to LPT Cable 3 Firmware Upgrade Procedure Step 1. Let VA502mb/VA702mb set to be connected with AC cable and VGA cable. Step 2.Execute the MSstar ISP tool. 29 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Step 3. Click “Config” button . Select the Port Type: LPT1 and the Base Addr : 0x378 on “Communication Setting” flame, and then the Speed: 47 on “E2PROM Device Setting” flame Step 4. Click “Connect” button. (On this step, if the connection is successful, the “Entry ISP Mode” Dialog will be showed. If not, the error dialog will be done.) Step 5. Click “Device” button. Select the “PMC25LV010” or “SST25VF010” viewed on your set. 30 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Step 6. Click “Read” button. Select the object bincode on your corresponding directory. Step 7. Click “Auto” button. Execute the flashing action by clicking the “Run” button. Step 8. If the flashing F/W has been completed, “Ok” message will be showed on the right TextBox. 31 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Step 9. Unplug and replug power cord of VA502mb/VA702mb set and then check the OSD operation and image on srceen. Step 10. At last, do “Memory Recall.” 3.2 Setup Procedure 3.2.1 Connect P2 and monitor of Fixture with VGA ports of VA502mb/VA702mb by VGA Cable. 3.2.2 Connect P1 of Fixture with Printer port of PC by LPT Cable. 3.2.3 Plug Power Adapter to Fixture. 3.2.4 Connect Power Cord to VA502mb/VA702mb Monitor. 3.2.5 Connect PC to the additional monitor. JP1: Power Adapter P2: VGA Cable P1:to LTP Cable 32 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 3.3 DDC Key In Procedure Sep1.Select and execute DDc Key In program Sep2:Inpute the S/N and execute “Enter” 33 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Sep3: Key the “Enter” and write the data Sep4: If ddc program OK and show “data compare ok” 34 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 5.7 Packing Procedure 35 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 7.1 Units Disassemble Process 7.1.1 Tools Glove Big cross screwdriver Small cross screwdriver Prize equipment or abandoned IC card Screw box Cushion Six angle sleeve spanner 7.1.2 Disassemble process 1、 2、 3、 4、 The whole monitor.(Picture 1) Remove the decorate slice and the stand.(Picture 2, 3) Disassemble the 4 screws that fix the back cover, remove the back cover. (Picture 4) Disassemble the shield and remove the aluminum foil .(Picture 5,6) 5、 Disassemble the screws for main board, power board, audio board and the connector or wire. (Picture 7,8) 6、 Disassemble the screws for the shielding. (Picture 9,10) 7、 The panel. (Picture 11) 7.1.3 Show pictures (Picture 1) (Picture 2) 36 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 (Picture 3) (Picture4) (Picture 5) (Picture 6) (Picture 7) 37 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 (Picture 8) (Picture 9) (Picture 10) (Picture11) 38 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 6. Troubleshooting Flow Chart 39 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 7. Block Diagram 40 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 8. Schematic Diagrams TSU16AK SCHEMATIC B2 B1 TXD RXD DDC_CLK DDC_DAT ST_DET1 ST_DET2 RIN GNDR GIN GNDG SOG BIN GNDB HSYNC VSYNC RIN GNDR GIN GNDG SOG BIN GNDB HSYNC VSYNC VCC2.5 VCC3.3 VAA1 VAA2 VAA3 VAA4 VCC2.5 VCC3.3 R+ RG+ GB+ BCLK+ CLK- R+ RG+ GB+ BCLK+ CLK- VAA1 VAA2 VAA3 VAA4 3.INPUT B3 ST_DET2 ST_DET1 DDC_CLK DDC_DAT RXD TXD VCPU VCC12V VCC5V CSZ SCL SDA HWRESET INT AD0 AD1 AD2 AD3 VCC5V VCC12V VCPU VCPU VCC12V VCC3.3 VCC2.5 VAA1 VAA2 VAA3 VAA4 VCC5V CSZ SCL SDA HWRESET INT AD0 AD1 AD2 AD3 Volume B5 PA[0..9] PA[0..9] PA[0..9] Volume onPANEL_5V/3.3V onBACKLITE PB[0..9] PB[0..9] VLCD PB[0..9] 6.MCU VLCD B4 onBACKLITE onPanel_5V/3.3V VCPU VCC12V VCC3.3 VCC2.5 AdjBACKLITE VAA1 VAA2 VAA3 VAA4 VCC5V VLCD 5.PANEL INTERFACE AdjBACKLITE VLCD 4.SCALER ViewSonic Corporation 2.POWER Model Title Date 41 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 MAIN BOARD Rev: VCC5V+ VCC5V SOT-252 D202 VCC12V VCC12V R202 6 CN201 10KΩ 1/16W R201 4.7KΩ 1/16W C210 D201 SS14 VCC5V+ VCC5V VCC5V C201 R212 4.7KΩ 1/16W 1 Q201 PMBS3904 0.1uF 3,4,6 VO GND ON_OFF DIM VCC12V GND VCC5V GND VI 0.1uF 2 VCC2.5 C211 4 C212 + 47uF/16V 0.1uF 1 2 4 6 8 10 12 3 1 3 5 7 9 11 3 VCC2.5 RT9164 onBACKLITE 6 2 GND GND VCC12V GND VCC5V GND U201 GS1D C VCPU FB201 600 OHM CONN VCPU B 6 E VCC5V C202 R203 1KΩ 1/16W C204 C203 + 220uF/25V 0.1uF 220uF/25V C205 + 0.1uF VCC3.3 Brightness 4 AdjBACKLITE R204 10KΩ 1/16W 3 R205 4.7KΩ 1/16W 1 VCC5V+ Q202 2 C B 4 VAA1 4 VAA2 4 VAA3 4 VAA4 4 TO-263 C206 1uF/25V PMBS3904 VCC3.3 3 E C214 0.1uF 1 U202 AIC1084-33M VIN ADJ VOUT VAA1 2 C215 47uF/16V + C216 VAA2 0.1uF VAA3 VAA4 NEW Circuit VCC5V VCC5V VLCD 5 VCC5V R214 delete R206 10KΩ 1/16W 4.7KΩ 1/16W R215 3 R216 6 onPanel_5V/3.3V 1 Q204 C207 100KΩ 1/16W Q203 AO3401 R209 0Ω 1/16W R210 R213 NC NC C217 0.068uF + 2 PMBS3904 4.7KΩ 1/16W VCC3.3 VCC12V R208 10KΩ 1/16W R207 VLCD 0.1uF C208 100uF/16V R211 10KΩ 1/16W ViewSonic Corporation Model Title Date 42 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 POWER Rev: 15 0Ω 1/16W R301 100Ω 1/16W C304 0.047uF FB302 0Ω 1/16W R302 100Ω 1/16W C305 0.047uF FB303 0Ω 1/16W R303 100Ω 1/16W C306 0.047uF R304 470Ω 1/16W C307 0.001uF R305 100Ω 1/16W C308 0.047uF R306 100Ω 1/16W C309 0.047uF R307 100Ω 1/16W C310 0.047uF PC5V R325 75Ω 1/16W VGA_CON C301 NC C302 NC C303 3 3 3 D323 TZMC5V6-GS08 TZMC5V6-GS08 D302 BAV99 D303 BAV99 VSI 1 2 4 SOG 4 GNDR 4 GNDG 4 GNDB 4 10KΩ 1/16W 100Ω 1/16W D320 TZMC5V6-GS08 4 BIN R308 150 OHM R312 D319 TZMC5V6-GS08 1 2 1 2 FB304 GIN VCC5V VCC5V HSI 4 NC D322 D301 BAV99 RIN R313 C311 R314 C312 2.2KΩ 1/16W 33pF 10KΩ 1/16W 220pF R309 100Ω 1/16W R310 1KΩ 1/16W R311 1KΩ 1/16W VCC5V ST_DET1 6 PC5V HSYNC 4 VSYNC 4 2 14 FB301 3 13 6 6 D304 BAV70 D317 TZMC5V6-GS08 1 12 RXD TXD R327 75Ω 1/16W 11 R326 75Ω 1/16W CN301 DB15 1 6 2 7 3 8 4 9 5 10 R317 10KΩ 1/16W CLK_DDC DAT_DDC R315 R316 R318 10KΩ 1/16W 8 7 6 5 100Ω 1/16W 100Ω 1/16W D318 TZMC5V6-GS08 6 6 0.1uF 1 2 3 4 A0 A1 A2 GND DDC_DAT DDC_CLK DVI5V 2 3 VCC5V D305 R319 R320 11 3 19 22 D314 LL5232B 5.6V 5% 100Ω 1/16W 100Ω 1/16W D315 LL5232B 5.6V 5% DVI5V D316 LL5232B 5.6V 5% BAV70 R321 10KΩ 1/16W R322 100Ω 1/16W C314 R323 0.1uF 10KΩ 1/16W D311 BAV99 3 D310 BAV99 3 D309 BAV99 3 D308 BAV99 3 D307 BAV99 3 D306 BAV99 3 18 17 10 9 2 1 13 12 5 4 21 20 23 24 JACK ST_DET2 6 1 CLK_DDC2 DAT_DDC2 3 DAT0+ DAT0DAT1+ DAT1DAT2+ DAT2DAT3+ DAT3DAT4+ DAT4DAT5+ DAT5clk+ clk- D321 TZMC5V6-GS08 25 26 27 29 28 8 15 6 7 14 16 3 1/3shield 2/4shield 0/5shield clk shield VCC WP SCL SDA M24C02WMN6 CN302 R G B RGB GND HSYNC VSYNC SYNC GND DDC SCL DDC SDA +5V HPD C313 U301 D312 BAV99 B+ BG+ GR+ R- 4 4 4 4 4 4 CLK+ CLK- 4 4 R324 10KΩ 1/16W C315 U302 8 7 6 5 VCC WP SCL SDA A0 A1 A2 GND 1 2 3 4 0.1uF M24C02WMN6 D313 BAV99 1 2 1 2 1 2 1 2 1 2 1 2 1 2 1 2 VCC5V ViewSonic Corporation Model Title Date 43 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 INPUT Rev: VCC3.3 FB401 3 3 3 3 3 3 3 3 VDVI 40 41 43 44 46 47 49 50 52 R+ RG+ GB+ BCLK+ CLKR403 390Ω 1/16W 66 C401 0.1uF 67 RIN0 RIN0M GIN0 GIN0M SOGIN0 BIN0 BIN0M HSYNC0 VSYNC0 DDC1_CLK/GPO8 DDC1_DAT/GPO7 VCC3.3 VCC2.5 FB402 2 600 OHM C405 10uF/16V VDD VCC2.5 VDD 600 OHM C414 10uF/16V + LVA3P LVA3M LVACKP LVACKM LVA2P LVA2M LVA1P LVA1M LVA0P LVA0M C406C407C408C409C410C411C412C413 0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF C415C416C417C418 0.1uF0.1uF0.1uF0.1uF 102 103 106 107 108 109 110 111 112 113 PA0 PA1 PA2 PA3 PA4 PA5 PA6 PA7 PA8 PA9 VAA1 FB403 PA[0..9] PA[0..9] VAA1 600 OHM C419 10uF/16V NC/LVB3P NC/LVB3M NC/LVBCKP NC/LVBCKM NC/LVB2P NC/LVB2M NC/LVB1P NC/LVB1M NC/LVB0P NC/LVB0M REFP 118 119 120 121 122 123 124 125 128 1 PB0 PB1 PB2 PB3 PB4 PB5 PB6 PB7 PB8 PB9 VAD 5 2 R+ RG+ GB+ BCK+ CKREXT + C420C421 0.1uF0.1uF PB[0..9] PB[0..9] 5 VAA2 2 VAA2 FB404 VPLL 600 OHM TSU16AK REFM + 18 87 97 117 VDDC VDDC VDDC VDDC 11 21 84 94 104 114 126 VPO VDDP VDDP VDDP VDDP VDDP VDDP VDDP 53 AVDD_PLL 45 51 35 AVDD_DVI AVDD_DVI 63 62 60 59 61 58 57 37 38 29 28 RIN GNDR GIN GNDG SOG BIN GNDB HSYNC VSYNC AVDD_MPLL 3 3 3 3 3 3 3 3 3 VPLLVDVI VDPLL AVDD AVDD U401 VAD 55 65 2 VPO C422 10uF/16V + C423 0.1uF 6 CSZ 6 SCL 6 SDA 6 HWRESET 6 INT 69 71 70 32 72 CSZ SCL SDA HWRESETZ INT VAA3 2 VAA3 C402 22pF 73 74 33 ADO/NC AD1/NC AD2/NC AD3/NC XIN GNDP GNDP GNDP GNDP GNDP GNDP GNDP 10 20 85 95 105 115 127 AVSS_DVI AVSS_DVI AVSS_DVI 39 42 48 68 56 64 30 77 78 31 AD0 AD1 AD2 AD3 6 6 6 6 C425C426 0.1uF0.1uF R402 VAA4 100Ω 1/16W 2 6 R401 NC AVSS_PLL BYPASS AVSS_LPLL 54 3 2 BUS TYPE/NC AVSS_MPLL 0.1uF XOUT AVSS AVSS AVSS C404 34 36 C403 22pF + VCC3.3 X401 14.318MHz C424 10uF/16V 10KΩ 1/16W 10KΩ 1/16W 10KΩ 1/16W 10KΩ 1/16W PWM0 PWM1 19 GNDC 86 GNDC 96 116 GNDC GNDC AdjBACKLITE Volume VDVI 600 OHM R407 R405 R404 R406 2 6 FB405 VCC5V VAA4 FB406 VDPLL 600 OHM C427 10uF/16V + C428 0.1uF Direct Bus 3-WIRE R401 R402 NC 4.7K 4.7K NC ViewSonic Corporation Model Title Date 44 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 SCALER Rev: 4 4 PA[0..9] PB[0..9] PA[0..9] PB[0..9] PA0 PA1 PA2 PA3 PA4 PA5 LVA3P LVA3M LVACKP LVACKM LVA2P LVA2M PA6 PA7 LVA1P LVA1M PA8 PA9 PB0 PB1 PB2 PB3 LVA0P LVA0M LVB3P LVB3M LVBCKP LVBCKM PB4 PB5 PB6 PB7 PB8 PB9 LVB2P LVB2M LVB1P LVB1M LVB0P LVB0M CN503 LVB0M LVB1M LVB2M LVBCKM LVB3M LVA0M LVA1M LVA2M LVACKM LVA3M RXO0RXO1RXO2RXOCRXO3RXE0RXE1RXE2RXECRXE3- 1 3 5 7 9 11 13 15 17 19 21 23 2 4 6 8 10 12 14 16 18 20 22 24 RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+ LVB0P LVB1P LVB2P LVBCKP LVB3P LVA0P LVA1P LVA2P LVACKP LVA3P CONN R502 0Ω 1/16W VLCD VLCD 2 C509 + C510 C511 47uF/16V 0.1uF 0.1uF ViewSonic Corporation Model Title Date 45 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 PANEL INTERFACE Rev: VCPU VCPU R601 RN601 C601 RN602 10KΩ 1/16W 0.1uF 10KΩ 1/16W 10KΩ 1/16W + RST D601 0.22uF INT 1 2 3 4 R604 10KΩ 1/16W R605 10KΩ 1/16W U602 A0 A1 A2 GND VCC WP SCL SDA 8 7 6 5 R639 R638 AT24C16N-10SC-2.7 NC CN601 VCC12V FB602 600 OHM VCC5V R627 R626 C612 0.1uF 0.1uF VCC5V EA/VP P0.0 P0.1 P0.2 P0.3 P0.4 P0.5 P0.6 P0.7 XTAL1 XTAL2 RESET P2.0 P2.1 P2.2 P2.3 P2.4 P2.5 P2.6 P2.7 P4.3 INT0/P3.2 INT1/P3.3 ALE/P PSEN P1.0 P1.1 P1.2 P1.3 P1.4 P1.5 P1.6 P1.7 T0/P3.4 T1/P3.5 P3.6/WR P3.7/RD P3.1/TXD P3.0/RXD 43 42 41 40 39 38 37 36 24 25 26 27 28 29 30 31 16 17 18 19 13 11 W78E65P-40 2 POWER ENTER RIGHT LEFT AUTO LED_B LED_O LED_G R636 R606 R607 2,3,4 R632 Standby Mute NC NC 100Ω 1/16W 100Ω 1/16W VCPU CN603 VCC5V 3 3 1 2 3 4 R631 NC NC ST_DET1 ST_DET2 R630 R633 DVI-DSUB SELECT Mute_key NC NC R643 NC R640 NC 1 Volume R641 NC C615 NC NC HWRESET 4 onPANEL_5V/3.3V 2 onBACKLITE 2 CSZ 4 SCL 4 SDA 4 VCPU AD0 AD1 AD2 AD3 DDC_DAT DDC_CLK TXD RXD R612R613 1 2 3 4 4 4 4 4 3 3 3 3 C618 0.1uF NC 10KΩ 1/16W NC 4 VCPU VCPU VCPU 2 NC Q604 C614 0Ω 1/16W 10KΩ 1/16W 10KΩ 1/16W R610 R611 R634 R635 VCPU 3 CONN C613 33 32 2 3 4 5 6 7 8 9 100Ω 1/16W 100Ω 1/16W 100Ω 1/16W 10KΩ 1/16W 10KΩ 1/16W OUT-R+ OUT-R- R608 R609 R615 10KΩ 1/16W R614 10KΩ 1/16W VCC12V FB601 600 OHM VCC5V OUT-L+ OUT-L- 12 14 15 VCPU C605 2 4 6 8 10 12 14 10 R603 4 LL4148-GS08 10KΩ 1/16W Reset Circuit 1 3 5 7 9 11 13 20 C604 22pF 2 1 VCC 20MHz C603 10uF/16V MAX810STR GND U603 3 21 U601 22 VCPU 35 VCC X601 VSS C602 22pF 44 1 2 3 4 1 2 3 4 10KΩ 1/16W R602 8 7 6 5 8 7 6 5 2 LED_G R616 4.7KΩ 1/16W AUTO R620 RIGHT R622 POWER R624 1 Q601 PMBS3906 CN602 DVI-DSUB SELECT LED_GRN 470Ω 1/16W 470Ω 1/16W 470Ω 1/16W C606 C608 C610 0.001uF 0.001uF 0.001uF OUT-L+ OUT-L- 1 3 5 7 9 11 13 15 2 4 6 8 10 12 14 16 LED_BLUE LED_ORANGE R637 Q603 PMBS3906 LED_B 1 R629 4.7KΩ 1/16W C616 1uF/25V C607 0.001uF Q602 PMBS3906 1 LED_O R619 4.7KΩ 1/16W 470Ω 1/16W R621 470Ω 1/16W R623 470Ω 1/16W Mute_key OUT-R+ OUT-R- 120Ω 1/16W 2 1uF/25V R618 0Ω 1/16W 120Ω 1/16W C611 2 100pF R628 R617 3 C617 0Ω 1/16W ENTER LEFT 3 R642 R625 10KΩ 1/16W 2 600 OHM 3 FB603 C609 0.001uF CONN ViewSonic Corporation Model Title Date 46 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 MCU Rev: 1 TP1 HVO 1 Q203 SI4431DY-T1 C201 150uF/25V C202 0.1uF/25V Q202 DTA144WKA C225 1uF/25V Q201 DTC144WKA NO/OFF R219 1KΩ 1/16W R218 100Ω 1/16W R201 47K R214 2.2KΩ 1/16W Q205 MPS3904 D201 SR24 R216 220Ω 1/16W C211 1uF/25V D203 RLZ11B R210 9.1KΩ1/16W R208 4.7KΩ 1/16W 5 C213 .15uF/160V R220 15KΩ Q209 2SC5706 1 2 9 CONN CN202 C216 22pF/6KV 1 2 3,4 Q210 2SC5706 1 2 6 1 1 7 2 POWER X'FMR R232 1KΩ 1/16W D207 1N4148 R238 12KΩ 1/16W CONN 4 3 TRANSFORMER D205 1N4148 R234 910Ω 1/16W C219 1uF/25V R236 470Ω 1/16W Vcc C204 0.1uF U201 BAF9741F 8 GND 9 10 2OUT 1OUT 11 2DTC 7 6 1DTC 12 2FBK 5 1FBK 13 2IN1IN- 14 2IN+ 1IN+ 4 3 SCP 15 L202 1N4148 RT 16 REF CT CN201 D209 R240 51KΩ 1/16W 2 1 PT201 R222 12KΩ 1/16W C221 0.47uF/25V C208 330pF TP4 HVL C215 22pF/6KV C209 1uF/25V C205 0.1uF/25V R207 NC R227 1KΩ 1/16W 3 Q207 MPS3906 R205 47KΩ C207 4.7uF R225 R226 1KΩ 1/16W 1KΩ 1/16W 3 C203 1uF/25V + R224 1KΩ 1/16W 1 DIM 1 L201 L 2 + 8 7 6 5 2 1 2 3 R212 4 3.9KΩ 1/16W +12V TP3 HVL R204 10KΩ 1/16W is power GND is signal GND ViewSonic Corporation Model Title Date 47 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 INVERTER Rev: R920 47Ω 1/2W T901 4 1 O + R906 1MΩ 1/4W C905 100uF/400V R904 C906 1MΩ 1/4W 0.0015uF/2KV R905 1MΩ 1/4W 3 R908 10Ω 1/16W D904 1N4148 R916 24KΩ 1/10W 2 GND R902 1MΩ 1/16W 7 8 5 6 1 SW_ON/OFF 4 SG6841 1 NC D906 ZD905 RLZ20B R914 NC FB901 C901 C902 0.001uF/160V 0.001uF/160V + + C925 1000uF/16V 10,11 C913 0.0047uF/250V C926 470uF/16V R918 20KΩ 1/4W C911 0.001uF ZD902 HZ12B2 R919 0.39Ω 2W PC123FY2 4P 3 R909 4.7KΩ 1/16W R912 100Ω 1/16W R913 NC C909 0.1uF Q902 2PC945P 3 C910 0.1uF CONN C927 0.1uF ZD903 HZ5C1 R927 1KΩ 1/10W R910 4.7KΩ 1/16W Q901 2PA733P GND GND 5V 5VA DIM ON/OFF R931 1KΩ 1/16W D903 1N4148 ZD901 RLZ20B FB902 BEAD 12V GND R930 470Ω 1/4W IC902 F901 FUSE 12 11 10 9 8 7 6 5 4 3 2 1 FB903 BEAD L904 D912 31DQ06 BEAD NR901 NTCR t ZD904 SML4737A/1 C928 0.1uF Q903 2SK2996 2 4 1N4148 R915 10KΩ 1/16W R917 JUMPER C912 NC 2 4 IC901 SG6841 CN902 1 6O C924 470uF/16V POWER X'FMR D905 1N4148 C904 0.47uF/250V C907 10uF 3 L 1 C908 0.1uF 3 2 + L902 7,8 5 CN102 + C922 1000uF/16V R922 C921 47Ω 1/4W 0.001uF/500V O 7,8 D902 PS102R 2 R907 1MΩ 1/4W 2 L903 R903 100KΩ 2W D901 FR107 TO INVERTER 1 3 R901 1MΩ 1/16W 9 + - 1 F902 FUSE D910 31DQ10 2 + BD901 2KBP06M C920 0.001uF/500V C936 0.1uF R924 33KΩ 1/10W R929 0Ω 1/16W IC903 HTL431 C935 0.01uF R911 4.7KΩ 1/16W R928 1KΩ 1/10W R925 3.6KΩ 1/10W R926 24KΩ 1/10W 1 CN901 SOCKET CN301 CN302 1 4 3 2 5 3 2 1 PHONEJACK INR GND INL CONN ViewSonic Corporation Model Title Date 48 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 POWER Rev: OUT_LOUT_R 12V CN202 WAFER 2*7P 2.54mm MUTE R212 33L8022-3A-H FEMALE 6 11 220KΩ C211 R211 C212 100 pF + C209 + C210 1.0uF 1.0uF C213 0.1uF 15 GND C205 CN203 + 16 U201 TDA7496L C203 0.1uF INL OUTL INR OUTR SVR VOLUME STBY VAROUT_R MUTE VAROUT_L 17 4 3 2 1 470uF/16V 14 10 C207 470uF/16V 7 5 R207 R208 WAFER 4P2.0 R/A GND + C208 470uF/16V 1 2 3 13 18 19 20 100 pF R210 5.6KΩ GND 5.6KΩ 12 C202 470uF/16V + 9 C201 470uF/16V 1KΩ C206 0.47uF 10KΩ + 1KΩ R203 4 + VS C204 0.47uF R201 10KΩ VS CN204 8 GND PIN-1 NC VOLUME 14 12 10 8 6 4 2 STANDBY 13 11 9 7 5 3 1 PIN-1 GND GND GND GND GND GND GND PIN-3 1 2 3 +12V GND GND GND GND ViewSonic Corporation Model Title Date 49 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 AUDIO BOARD Rev: 9. PCB Layout Diagrams MAIN BOARD 50 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 POWER BOARD 51 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 52 68 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 53 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 AUDIO BOARD 54 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 KEY BOARD 55 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 10. Exploded Diagram and Exploded Parts List 56 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 EXPLODED PARTS LIST (VA502mb-1) ViewSonic Model Number: VS11352 Rev: 1a Serial No. Prefix: QA8 Item ViewSonic P/N N/A 1 2 B-00008246 N/A 3 N/A 4 N/A 5 N/A 6 N/A 7 N/A 8 N/A 9 N/A 10 N/A 11 12 B-00008247 13 B-00008244 14 B-00008245 N/A 15 N/A 16 N/A 17 Ref. P/N Description Q'ty 78G314-2-G Speaker 2 1 KEPC560KE3O9P Key pad 81G12-2-GP LED 1 Q33G4713-E7-1L KEY PAD 1 Q34G1274-E7-1L BASE 1 37G495-1 HINGE 1 Q34G1273-E7-1L STAND 1 33G4695-1-C CLAMP 1 15G5791-1 Vesa BKT 1 Q34G1298-E7-2L Rear cover 1 85G654-3 Main shield 1 PKCC1521SVE1P Power board 1 AUPC560KBO9P Audio Board 1 CBPC560KV8V29P Main board 1 15G5935-25-CKD Main Frame 1 750GLD50-4TB-31 Panel 1 Q34G1295-E7-A3L Bezel 1 57 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Packing for Shipping 58 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 PACKING PART LIST ( VA502mb-1 ) ViewSonic Model Number: VS11352 Rev: 1a Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 44B352-6 Q50G600-2/3 Q45G76-28-CK2 Q70G1500-709-1B Q41G7800-709-19A Q45G88-609 VA502mb 45G88-609 Q45G88-607-CK2 45B3553-1/2 89G173-56-4B 89G402A-15N-IS1 89G715-CAA-D N/A Location Carton HANDLE 1/2 PE BAG CD manual QSG EPE cover Monitor EPE cover PE BAG EPS AUDIO CABLE POWER CABLE SIGNAL CABLE DVI CABLE Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 0 59 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 11. Recommended Spare Parts List RECOMMENDED SPARE PARTS LIST ( VA502MB-1 ) ViewSonic Model Number: VS11352 Serial No. Prefix: QA8 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 Accessories: PC Board Assembly: Cabinets: Cables: Documentation: Electronic Components: Hardware: Packing Material: Plastics: Rev: 1a Description ECR/ECN ViewSonic P/N Power Cord A-00008091 Audio Control Board B-00008244 Sub Board - Conversion Board B-00008245 Key Board B-00008246 Power Supply Board B-00008247 Front Panel C-00008252 Back Cover C-00008253 Audio Cable CB-00008105 Video Cable CB-00008106 Wire - for Audio Board CB-00008107 Wire CB-00008108 Quick Start Guide DC-00008209 User's Guide DC-00008210 Label - Carton Label DC-00008211 S/N LABEL DC-00008212 AIC1084-33PM TO-263 E-00005651 Audio Integrated Circuit (E-TDA749) E-00008115 Integrated Circuit - RTD2523B-LF PQFP-128 E-00008254 Integrated Circuit - MTV512MV PLCC-44 E-00008255 Integrated Circuit - M24C02-WMN6TP E-00008256 Integrated Circuit - M24C02-WMN6TP E-00008257 LCD Panel - (SVA150XG04TB) E-00008258 Screw HW-00003747 Screw HW-00003750 Screw HW-00004993 Hinge HW-00008073 Screw HW-00008074 Screw HW-00008075 Screw HW-00008076 Screw HW-00008077 Screw HW-00008078 Screw HW-00008079 PE BAG P-00005645 EPS(R) P-00008249 EPS(R) P-00008250 PE BAG P-00008251 PE BAG FOR BASE P-00008252 Pedestal PL-00008084 Ref. P/N Location Universal number# 89G402A15NIS1 AUPC560KBO9P CBPC560KV8V29P KEPC560KE3O9P PKCC1521SVE1P Q34G1295 E7A3L Q34G1298 E7 2L 89G 173 56 4B 89G 715LAA D 95G8014 16618 95G8018 14507 Q41G780070919A Q70G1500709 1A 40G 581709 1A 40G 15N709 1A 56G 563 7 U202 56G 616 1 U201 56G 562 57 U401 56G1125137ET2 U601 56G1133 20 U301 56G1133516 U602 750GLD504TB 31 M1G1730 6128 Q1G 330 6120 Q1G1030 8128 37G 495 1 M1G 330 4128 M1G 330 6 47 M1G1140 5128 AM1G1740 10 47 Q1G 330 10 47 Q1G1030 10128 45G 88609 44B3524 1 44B3524 2 45G 76 28CK2 45G 88607CK2 Q34G1274 E7 1L 20 Remark 1: Above listed items are examples, supplier can expand the rows to add more necessary items. Remark 2: All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to eliminate repeated cross checks of each item between this version and prior versions. 60 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 BOM LIST ( VA502mb-1 ) ViewSonic Model Number: VS1135 Rev: 1a Serial No. Prefix: QA8 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 ViewSonic P/N B-00008245 B-00008246 B-00008247 B-00008244 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A E-00008258 N/A N/A PL-00008084 C-00008252 C-00008253 N/A DC-00008209 N/A N/A N/A N/A N/A Ref. P/N CBPC560KV8V29P KEPC560KE3O9P PKCC1521SVE1P AUPC560KBO9P 007G 5 7110 015G5791 1 015G5908 2 015G5935 25CKD 023G3178709 3A 033G4714 1 C 040G 154501 1 040G 581 26646 040G 581625 2A 040G 581709 1A 040G 58170918D 044G3231 15528 044G3553 1 044G3553 2 044G6000 4E 045G 76 28CK2 045G 77 3 045G 77500 045G 77501 045G 88607CK2 045G 88609 052G 1150 C 052G 1174 2A 052G 1185 052G 1185 1 052G 1186 052G 1191 052G 1192 052G 1211 A 052G 4 1 052G6020 2 078G 314 2 078G 314 2 G 085G 654 3 089G 173 56 4B 089G 715CAA D 089G 715LAA D 089G402A15NIS1 095G8014 16584 095G8018 14507 0M1G 330 4128 CR3 0M1G 330 4128 CR3 0M1G 330 6 47 CR3 0M1G1140 5128 CR3 0M1G1730 6128 CR3 0Q1G 330 6120 0Q1G 330 10 47 CR3 705LQ5K0P34001 750GLD504TB 31 AM1G1740 10 47 CR3 Q33G4713 E7 1L Q34G1274 E7 1L 20 Q34G1295 E7A3L Q34G1298 E7 2L Q40G 15N709 1C Q41G780070919A Q45G 76 28A07 Q70G1500709 1B 705LQ5K0P34001 012G 394 1 033G4695 1 C Description CONVERSION BOARD KEY BOARD POWER BOARD AUDIO BOARD COMPOUND PALLET VESA BKT BRACKET MAIN FRAME LOGO POWER LENS HI-POT GND LABEL EANCODE LABEL PALLET LABEL CARTON LABEL PALLET LABEL EVA WASHER EPS(L) EPS(R) CARTON PE BAG PE BAG BARCODE RIBBON BARCODE RIBBON PE BAG EPE COVER WHITE TAPE 3M 69# MIDDLE TAPE FOR CARTON BIG TAPE SMALL TAPE GLASS CLOTH GLASS CLOTH 165MINIUM TAPE SMALL TAPE PROTECT FILM 4028 SPEAKER 8OHM 1W SPEAKER SHIELD AUDIO CABLE SIGNAL CABLE SIGNAL CABLE POWER CORD WIRE HARNESS HARNESS SCREW SCREW SCREW SCREW SCREW SCREW SCREW 15" LCD STAND ASS'Y SVA 15" PANEL SCREW KEY PAD BASE BEZEL REAR COVER RATING LABEL QSG PE BAG cd manual 15" LCD STAND ASS'Y FOOT PORON CLAMP Location Universal number# M044A M044B PE089B1 PE089B1 E089A E750L Q'ty 1 1 1 1 0.01 1 1 1 1 1 1.1 0.5 0.05 1 0.05 1 1 1 0.035 1 173 22 1.8 1 1 20 31 65 160 20 450 450 1 0.95 0.1 2 1 1 1 1 1 1 1 1 4 1 4 1 9 4 1 1 1 4 1 1 1 1 1 1 1 1 0 6 1 61 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 ViewSonic P/N N/A N/A N/A N/A B-00008244 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A B-00008246 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A B-00008247 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 037G 495 1 0Q1G1030 8128 CR3 0Q1G1030 10128 CR3 Q34G1273 E7 1L AUPC560KBO9P 033G802414C H 056G 616 1 090G6059 1 095G8014 3503 AU560KBO9SMTP 033G801714A H 033G8027 12 033G8027 14 H 033G8027 16 040G 45762412B 067G215B221 4H 067G215B221 4H 067G305V100 3 067G305V100 3 067G305V100 3 067G305V100 3 067G305V100 3 067G305V100 3 067G305V100 3 067G305V100 3 067G305V470 3 067G305V470 3 088G 35315F HS 088G 35315FHSJ 093G 22 53 093G 22 53 J 093G 22 55 093G 22 55 J AIC560KV8V29P KEPC560KE3O9P 033G3802 2H 033G3802 2H 033G801712A H 077G 603 2 CJ 077G 603 2 CJ 077G 603 2 CJ 077G 603 2 CJ 077G 603 2 CJ 081G 12 2 GP 088G 30211K AIK560KE39P PKCC1521SVE1P 033G3278 3 033G8020 2D U 033G8020 2D U 040G 45762412B 051G 6 4500 051G 6 4502 051G 6 4503 056G 139 3 056G 139 3A 056G 139 3B 056G 379 77 057G 723 3B 057G 724 4 057G 724 4A 057G 761 6 057G 761 6 061G 58080 WT 061G152M104 64 063G 10747410S 063G107K474 US 063G210J2242AC 065G 2K152 5E6052 065G 2K152 5E6285 Description HINGE ASS'Y SCREW SCREW STAND AUDIO BOARD 2*7PIN DUAL ROW RIGHT ANGLE H TDA7496 HEAT SINK WIRE HARNESS AUDIO BOARD FOR SMT PIN HEADER 2*7 R/A WAFER 2*6P 2.0MM R/A WAFER 14P 2.0MM DIP WAFER 16PIN 2.0mm DIP CBPC LABEL LOW E.S.R 220UF +-20% 25V LOW E.S.R 220UF +-20% 25V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 10UF +-20% 16V 105C 47UF +-20% 16V 105C 47UF +-20% 16V D-SUB 15P D-SUB 15PIN CONNECTOR CRYSTAL 14.318MHzHC-49US 14.31818MHZ/32PF/49US CRYSTAL 20MHZ HC-49US 20MHz/20PF/49US MAIN BOARD FOR AI KEY BOARD WAFER 2P RIGHT ANGLE WAFER 2P RIGHT ANGLE PIN HEADER 2*6 R/A TACT SWITCH TACT SWITCH TACT SWITCH TACT SWITCH TACT SWITCH GP36032ME/50-ZO PHONE JACK 5PIN KEY BOARD FOR AI POWER BOARD 3P PLUG B3B-XHA/JST WAFER WAFER CBPC LABEL RTV胶 RTV胶 RTV胶 PC123FY2 BY SHARP PC123Y22FZOF PC123 Y82FZ0F IC LD7552BPN DIP-8 2SK2761-01MR 2SK2996 STP9NK60ZEP 2SC5706-P-E 2SC5706-P-E 8 OHM NCT 100KOHM 5% 2W 塑胶膜电容 0.47UF +-10% FILM CAP 0.22UF J 250V 1500 PF 10% 2KV Y5P 1500 PF 10% 2KV Y5P Location Universal number# CN202 U201 CN204 CN601 CN201 CN503 CN602 C204 C202 C509 C427 C424 C422 C419 C414 C405 C208 C215 C211 CN301 CN301 X401 X401 X601 X601 CN103 CN104 CN101 SW105 SW103 SW102 SW101 SW104 DP101 CN102 CN302 CN202 CN201 P051 P051 P051 IC902 IC902 IC902 IC901 Q903 Q903 Q903 Q210 Q209 NR901 R903 C904 C904 C213 C906 C906 Q'ty 1 1 2 1 0 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 1 1 1 1 1 1 1 1 1 1 1 0 1 1 1 1.03 2 1 1 1 0 0 1 1 0 0 1 1 1 1 1 0 1 1 0 62 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 065G 2K152 5E6921 065G 6J2206E3 065G 6J2206E3 065G305M1022BP 065G305M1022BP 065G305M1022E2 065G305M1022E2 065G306M4722BM 065G306M4722BP 067G215S10115N 067G215V102 3N GP 067G215V102 3N GP 067G215Y4713NV 067G215Y4713NV 067G215Y4713NV 073G 174 30LSA 073G 174 30YSA 073G 253 91 H 073G 253 91 H 073G 253 91 L 073G 253 91 L 073G 253 91 LS 073G 253 91 LS 073G 253139 HA 073G 253139 SA 073G 253139 YA 073G 253139LSA 073L 174 26LSG 073L 174 26T1G 080LL15T 7DNG 080LL17T 2 LG 080LL17T 2 TG 080LL17T 2LSG 084G 7H200 SL 088G 30229C 088G 30229T 093G 50460 8 093G3006 1 095G8021 12520 705G 560 61 09 705G 780 57 02 705G 780 57 06 PKC521SE1SMTP S80LL15T7VG AU560KBO9SMTP 061L0603102 061L0603102 061L0603183 061L0603183 061L0603203 061L0603203 065G0805101 31 065G0805101 31 065G0805104 32 065G0805104 32 065G0805474 22 065G0805474 22 AUPC560KB4AIP AIC560KV8V29P 040G 457624 1B 056G 562 57 056G 563 7 056G 585 7 056G 643 9 056G 643 5A 056G1125137 X 056G1133 20 056G1133 24 056G1133 56 057G 417 4 Description 1500 PF 10% 2KV Y5P R 22PF J 6KV NP0 R 22PF J 6KV NP0 Y2 1000PF M 250VAC Y5P Y2 1000PF M 250VAC Y5P 1000P 400VAC/250VAC 1000P 400VAC/250VAC 4700PF +-20% 400VAC 4700PF +-20% 400VAC PAG450VB100-M-L18*35.5MM KY10VB1000M-CC3 10*16 KY10VB1000M-CC3 10*16 KY16VB470M-CC3 8*15MM KY16VB470M-CC3 8*15MM KY16VB470M-CC3 8*15MM FILTER FILTER CHOKE COIL CHOKE COIL CHOKE BY LI TA CHOKE BY LI TA CHOKE BY LI SHIN CHOKE BY LI SHIN CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL COMMON CHOKE LINE LILT 0.45MM X'FMR ADAPTOR BY LITAI X'FMR ADAPTOR BY LISHIN 250V/2A LIHEL FUSE PHINE JACL AUDIO IN JACK BRIDGE 2KBP06M2A600V 31DQ06FC WIRE HARNESS R919 ASS'Y (ROHS) CN901 ASS'Y (ROHS) D910 ASS'Y (ROHS) POWER BOARD FOR SMT 变压器组件 AUDIO BOARD FOR SMT CHIPR 1K OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIP 18K OHM 1/10W CHIP 18K OHM 1/10W CHIPR 20K OHM+-5% 1/10W CHIPR 20K OHM+-5% 1/10W CHIP 100PF 50V NPD 0805 CHIP 100PF 50V NPD 0805 CHIP 0.1U 50V X7R CHIP 0.1U 50V X7R CHIP 0.47UF 25V X7R 0805 CHIP 0.47UF 25V X7R 0805 AUDIO BOARD FOR AI MAIN BOARD FOR AI LABEL-CPU MST8011B-LF PQFP-128 AIC1084-33PM RT9164-25PL EM6353BZ2SP3B-2.9 MAX810 STRG W78E065A40PL PLCC44 AT24C02N-10SU-2.7 AT24C16AN-10SU-2.7 M24C16-WMN6TP PMBS3904/PHILIPS-SMT(04) Location C906 C215 C216 C901 C902 C901 C902 C913 C913 C905 C925 C922 C926 C924 C201 L202 L202 L903 L904 L903 L904 L903 L904 L201 L201 L201 L201 L902 L902 PT201 T901 T901 T901 F901 CN301 CN301 BD901 D912 CN102 Universal number# PT201 R208 R207 R203 R201 R211 R210 C212 C211 C213 C203 C206 C204 U401 U202 U201 U603 U603 U601 U301 U602 U602 Q204 Q'ty 0 1 1 1 1 0 0 1 0 1 1 1 1 1 1 1 0 1 1 0 0 0 0 1 0 0 0 0 1 1 1 0 0 1 1 0 1 1 1 1 1 1 0 1 0 1 1 1 1 1 1 1 1 1 1 1 1 1 0 1 1 1 1 1 0 1 1 1 0 1 63 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252 253 254 255 256 257 258 259 260 261 262 263 264 265 266 267 268 269 270 271 272 273 274 275 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 057G 417 4 057G 417 4 057G 417 6 057G 417 6 057G 763 1 061L 125472 8 061L 125472 8 061L0603000 061L0603000 061L0603000 061L0603000 061L0603000 061L0603000 061L0603000 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603101 061L0603102 061L0603102 061L0603102 061L0603102 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603103 061L0603104 061L0603121 061L0603222 061L0603222 061L0603330 061L0603330 061L0603390 0F 061L0603391 061L0603471 061L0603471 061L0603471 061L0603471 061L0603471 Description PMBS3904/PHILIPS-SMT(04) PMBS3904/PHILIPS-SMT(04) PMBS3906/PHILIPS-SMT(06) PMBS3906/PHILIPS-SMT(06) A03401 SOT23 BY AOS(A1) CHIP AR 8P4R 4.7K OHM+-5%1/16W CHIP AR 8P4R 4.7K OHM+-5%1/16W RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 100 OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W RST SM 0603 RC0603 100K CHIPR 120 OHM 1/10W CHIPR 2.2K OHM+-5% 1/16W CHIPR 2.2K OHM+-5% 1/16W CHIPR 33 OHM +-5% 1/10W CHIPR 33 OHM +-5% 1/10W CHIP 390 OHM 1/10W 1% CHIP 390 OHM 1/10W CHIPR 470 OHM+-5% 1/16W CHIPR 470 OHM+-5% 1/16W CHIPR 470 OHM+-5% 1/16W CHIPR 470 OHM+-5% 1/16W CHIPR 470 OHM+-5% 1/16W Location Q202 Q201 Q602 Q601 Q203 RN602 RN601 R642 R636 R502 R210 FB303 FB302 FB301 R305 R306 R634 R635 R609 R402 R608 R307 R309 R312 R322 R639 R303 R302 R301 R203 R310 R311 R624 R407 R406 R405 R404 R321 R318 R317 R601 R602 R604 R605 R606 R607 R613 R625 R626 R627 R314 R308 R211 R208 R206 R204 R202 R215 R618 R617 R313 R316 R315 R403 C510 R623 R622 R621 R620 R304 Universal number# Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 64 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 276 277 278 279 280 281 282 283 284 285 286 287 288 289 290 291 292 293 294 295 296 297 298 299 300 301 302 303 304 305 306 307 308 309 310 311 312 313 314 315 316 317 318 319 320 321 322 323 324 325 326 327 328 329 330 331 332 333 334 335 336 337 338 339 340 341 342 343 344 345 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 061L0603472 061L0603472 061L0603472 061L0603472 061L0603472 061L0603472 061L0603750 061L0603750 061L0603750 065G0603101 31 065G0603102 32 065G0603102 32 065G0603102 32 065G0603102 32 065G0603102 32 065G0603102 32 065G0603104 12 065G0603104 12 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603104 32 065G0603220 31 065G0603220 31 065G0603220 31 065G0603220 31 065G0603221 31 065G0603224 17 065G0603224 32 065G0603330 31 065G0603473 32 065G0603473 32 065G0603473 32 065G0603473 32 065G0603473 32 065G0603473 32 065G0603683 32 065G0805105 17 065G0805105 22 071G 56G151 A 071G 56Z601 071G 56Z601 Description CHIPR 4.7K OHM +-5% 1/16 CHIPR 4.7K OHM +-5% 1/16 CHIPR 4.7K OHM +-5% 1/16 CHIPR 4.7K OHM +-5% 1/16 CHIPR 4.7K OHM +-5% 1/16 CHIPR 4.7K OHM +-5% 1/16 CHIPR 75 OHM+-5% 1/16W CHIPR 75 OHM+-5% 1/16W CHIPR 75 OHM+-5% 1/16W CER1 0603 NP0 50V 100P PM5 R 1000PF +-10% 50V X7R 1000PF +-10% 50V X7R 1000PF +-10% 50V X7R 1000PF +-10% 50V X7R 1000PF +-10% 50V X7R 1000PF +-10% 50V X7R CER2 0603 X7R 16V 100N P CER2 0603 X7R 16V 100N P CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CHIP 0.1UF 50V X7R CER1 0603 NP0 50V 22P PM CER1 0603 NP0 50V 22P PM CER1 0603 NP0 50V 22P PM CER1 0603 NP0 50V 22P PM CER1 0603 NP0 50V 220P P CAP:CER 0.22UF-20%-80% 1 CHIP 0.22UF 50V X7R CER1 0603 NP0 50V 33P PM CHIP 0.047UF 50V X7R CHIP 0.047UF 50V X7R CHIP 0.047UF 50V X7R CHIP 0.047UF 50V X7R CHIP 0.047UF 50V X7R CHIP 0.047UF 50V X7R CHIP 0.068UF 50L X7R chip ceramic cap 1UF 16V CHIP 1UF 25V X7R 0805 TB160808G151 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 Location R619 R616 R212 R207 R205 R201 R327 R325 R326 C617 C610 C307 C606 C609 C608 C607 C613 C612 C406 C407 C408 C409 C410 C411 C412 C413 C415 C416 C417 C618 C601 C418 C420 C421 C423 C425 C426 C428 C511 C201 C203 C205 C207 C210 C212 C214 C216 C313 C401 C404 C604 C602 C403 C402 C312 C605 C605 C311 C305 C306 C308 C309 C310 C304 C217 C611 C206 FB304 FB601 FB406 Universal number# Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 1 1 1 1 1 1 1 1 1 1 1 1 1 65 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 346 347 348 349 350 351 352 353 354 355 356 357 358 359 360 361 362 363 364 365 366 367 368 369 370 371 372 373 374 375 376 377 378 379 380 381 382 383 384 385 386 387 388 389 390 391 392 393 394 395 396 397 398 399 400 401 402 403 404 405 406 407 408 409 410 411 412 413 414 415 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A E-00006392 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 071G 56Z601 071G 56Z601 071G 56Z601 071G 56Z601 071G 56Z601 071G 56Z601 071G 56Z601 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 071G 56Z601 M 093G 39147 093G 39147 093G 39147 093G 39147 093G 39147 093G 39147 093G 39147 093G 39147SEM 093G 39147SEM 093G 39147SEM 093G 39147SEM 093G 39147SEM 093G 39147SEM 093G 39147SEM 093G 39149 093G 39149 093G 39149 093G 39149 093G 39149 093G 39149 093G 39149 093G 64 42 P 093G 64 42 PP 093G 6433P 093G 6433P 093G 6433P 093G1004 3 093G1020 1 S 715G1237 2 3 056G1133 34 AIK560KE39P 061G 60251152T 061G 60251152T 715G1244 2 A 705G 560 61 09 061G 2J39858H 096G 29 6 705G 780 57 02 087G 501 12 CJ 087G 501 12 RF 095G205S354022 096G 29 6 705G 780 57 06 093G3010 1 A Q90G 410 4 PKC521SE1SMTP 056G 566 10 056G 622 1 057G 760 4 057G 760 5 057G 760 4B 057G 760 5B 057G 763 3 057G 763 4 Description CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600 OHM 0805 CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM CHIP BEAD 600OHM TZMC5V6 TZMC5V6 TZMC5V6 TZMC5V6 TZMC5V6 TZMC5V6 TZMC5V6 ZMM5V6ST ZMM5V6ST ZMM5V6ST ZMM5V6ST ZMM5V6ST ZMM5V6ST ZMM5V6ST MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT MLL5232B BY FULL POWER SMT BAV70 SOT-23 BAV70 SOT-23 BAV99 BAV99 BAV99 SS14 GS1D MAIN BOARD M24C02-WMN6TP KEY BOARD FOR AI 510 OHM 5% 1/6W 510 OHM 5% 1/6W KEY BOARD R919 ASS'Y (ROHS) 0.390OHM 5% 2W H.S. TUBE CN901 ASS'Y (ROHS) AC SOCKET AC SOCKET HARNESS H.S. TUBE D910 ASS'Y (ROHS) 31DQ10 HEAT SINK POWER BOARD FOR SMT SI4431DY-T1-SMT BA9741F-SMT DTA144WKA BY ROHM SMT DTC144WKA BY ROHM SMT PDTA144WK SOT346 PDTC144WK SOT346 AO4411 SO-8 RSS050P03 Location FB405 FB404 FB403 FB402 FB401 FB603 FB201 FB601 FB603 FB201 FB401 FB402 FB403 FB404 FB405 FB406 D320 D319 D318 D317 D321 D322 D323 D317 D318 D319 D320 D321 D322 D323 D323 D322 D321 D320 D319 D318 D317 D304 D304 D303 D302 D301 D201 D202 Universal number# U301 R102 R101 R919 CN901 CN901 D910 Q203 U201 Q202 Q201 Q202 Q201 Q203 Q203 Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1 0 1 1 1 1 1 1 1 0 1 1 1 0 1 10 0 1 0 1 20 0 1 1 0 1 1 1 1 0 0 1 0 66 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 416 417 418 419 420 421 422 423 424 425 426 427 428 429 430 431 432 433 434 435 436 437 438 439 440 441 442 443 444 445 446 447 448 449 450 451 452 453 454 455 456 457 458 459 460 461 462 463 464 465 466 467 468 469 470 471 472 473 474 475 476 477 478 479 480 481 482 483 484 485 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 061L0603000 061L0603000 061L0603101 061L0603102 061L0603103 061L0603103 061L0603123 061L0603221 061L0603222 061L0603392 061L0603511 061L0603513 061L0603911 061L0603912 061L0805100 3F 061L0805102 061L0805102 061L0805221 061L0805240 1F 061L0805330 2F 061L0805360 1F 061L1206101 061L1206102 061L1206102 061L1206103 061L1206105 061L1206105 061L1206105 061L1206105 061L1206242 061L1206242 061L1206242 061L1206242 061L1206472 061L1206472 061L1206472 061L1206684 061L1206684 065G0603471 32 065G0603471 32 065G0805104 22 065G0805104 22 065G0805104 32 065G0805104 32 065G0805104 32 065G0805105 27 065G0805105 27 065G0805105 27 065G0805105 27 065G0805105 27 065G0805331 31 065G0805471 31 065G0805474 27 093G 39S 3 T 093G 39S 8 T 093G 39S 16 T 093G 39S 19 T 093G 39S 20 T 093G 39S 23 T 093G2004 1 093G2004 3 093G2004 2A 093G3004 1 093G3004 2 PC1521SVA1AIP S80LL15T7VG AUPC560KB4AIP 715G1144 1 IO 095G 90 23 095G 90 23 Description RST SM 0603 JUMP MAX 0R0 RST SM 0603 JUMP MAX 0R0 CHIPR 100 OHM +-5% 1/16W CHIPR 1K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIPR 10K OHM +-5% 1/16W CHIP 12K OHM 1/16W CHIPR 220 OHM+-5% 1/16W CHIPR 2.2K OHM+-5% 1/16W CHIP 3.9K OHM 1/16W CHIPR 510 OHM+-5% 1/16W CHIP 51K OHM CHIP 910 OHM 1/16W CHIPR 9.1KOHM +-5% 1/10W CHIP 100KOHM +-1% 1/8W CHIPR 1K OHM +-5% 1/10W CHIPR 1K OHM +-5% 1/10W CHIPR 220 OHM +-5% 1/8W CHIPR 2.4KOHM +-1% 1/8W CHIP 33KOHM 1/8W 1% CHIP 3.6KOHM 1/8W 1% CHIP 100 OHM 5% 1/8W CHIP 1K OHM 5% 1/8W CHIP 1K OHM 5% 1/8W CHIP 10KOHM 5% 1/4W CHIP 1MOHM 5% 1/4W CHIP 1MOHM 5% 1/4W CHIP 1MOHM 5% 1/4W CHIP 1MOHM 5% 1/4W CHIPR 2.4K OHM+-5% 1/8W CHIPR 2.4K OHM+-5% 1/8W CHIPR 2.4K OHM+-5% 1/8W CHIPR 2.4K OHM+-5% 1/8W CHIP 4.7KOHM 5% 1/4W CHIP 4.7KOHM 5% 1/4W CHIP 4.7KOHM 5% 1/4W CHIPR 680K OHM+-5% 1/8W CHIPR 680K OHM+-5% 1/8W CHIP 470PF 50V X7R CHIP 470PF 50V X7R 0.1UF +-10% 25V X7R 080 0.1UF +-10% 25V X7R 080 CHIP 0.1U 50V X7R CHIP 0.1U 50V X7R CHIP 0.1U 50V X7R CHIP 1UF Y5V 0805 CHIP 1UF Y5V 0805 CHIP 1UF Y5V 0805 CHIP 1UF Y5V 0805 CHIP 1UF Y5V 0805 CHIP 330pF 50V NPO CHIP 470PF 50V NPO CHIP 0.47UF 25V Y5V BZT52-C11 RLZ11B LLDS SML4737A/1 PTZ7.5B RLZ22B LLDS GLZ22B SMAL240LVXRO-SMT SSM24PT SM240A DO-214AC SMAL340XXXRO 3A 40V SMA FULL P SR34 PAN JIT POWER BOARD FOR AI 变压器组件 AUDIO BOARD FOR AI AUIDO BOARD JUMPER JUMPER Location R208 R929 R218 R931 R222 R204 R238 R216 R214 R212 R236 R240 R234 R210 R916 R928 R927 R940 R926 R924 R925 R912 R232 R219 R915 R905 R904 R902 R901 R225 R224 R226 R227 R909 R910 R911 R906 R907 C398 C399 C205 C202 C928 C927 C910 C225 C219 C211 C209 C203 C208 C940 C221 D203 D203 ZD904 ZD904 ZD901 ZD901 D201 D201 D201 D201 D201 Universal number# J204 J203 Q'ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 0 1 0 1 0 1 0 0 0 0 1 0 0 1 1 1 67 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item 486 487 488 489 490 491 492 493 494 495 496 497 498 499 500 501 502 503 504 505 506 507 508 509 510 511 512 513 514 515 516 517 518 519 520 521 522 523 524 525 526 527 528 529 530 531 532 533 534 535 536 537 538 539 540 541 542 543 544 545 546 547 548 549 550 551 552 553 554 555 ViewSonic P/N N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Ref. P/N 095G 90 23 095G 90 23 061G 60220152T 067G 3054713XT 067G 3054713XT 067G 3054713XT 067G 3054713XT 067G 3054713XT 067G 3091097XT 067G 3091097XT PC1521SVA1AIP 006G 31500 006G 31502 006G 31502 006G 31502 006G 31502 006G 31502 006G 31502 061G 60275352T 715G1034 3 N2 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 061G 17210052T 061G 17210152T 061G 17210352T 061G 17268952T 061G 20747052T 061G 20747052T 061G 60218352T 061G 60247352T 071G 55 19 T 071G 55 29 093G 39 5452T 093G 39 7752T 093G 6038P52T 093G 64 1152T 093G 64 1152T 093G 64 1152T 093G 64 1152T 056G 158 4 T 057G 414 2 057G 417 3 T 057G 419 PP T 057G 420 PP T 064G700J1020AT 064G700J1040AT 064G700J1040AT 064G700J1040AT 065G 450104 7T 065G517K102 5T6921 065G517K102 5T6921 Description JUMPER JUMPER CFR 200 OHM +-5% 1/6W 470 uf 16v 470 uf 16v 470 uf 16v 470 uf 16v 470 uf 16v 1.0uF +-20% 50V 1.0uF +-20% 50V POWER BOARD FOR AI EYELET 1.5MM RIVET 1.5MM RIVET 1.5MM RIVET 1.5MM RIVET 1.5MM RIVET 1.5MM RIVET 75KOHM 5%1/6W PCB JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER JUMPER 100HM 5% 1/4W 100 OHM 5% 1/4W CFR 10KOHM +-5% 1/4W 6.8OHM 5% 1/4W 47 OHM 1/2W 47 OHM 1/2W 18KOHM 5% 1/6 47KOHM 5% 1/6W FERRITE BEAD D9X3. 5X0.8 FERRITE BEAD HZ12B2-E HZ5C1-E PS102R 1N4148 1N4148 1N4148 1N4148 H431BA MPS3906 MPS3904 2PC945P 2PA733P 1000PF 50V PEN 0.1UF 50V PEN 0.1UF 50V PEN 0.1UF 50V PEN 0.1UF +80-20% 50V Y5V 1000PF +-10% 500V Y5P 1000PF +-10% 500V Y5P Location J202 J201 R212 C208 C207 C205 C202 C201 C210 C209 Universal number# CN901 T901 Q903 PT201 NR901 L902 C905 R201 J108 J109 J110 J111 J112 J113 J906 J905 J904 J903 J902 J901 J116 J114 J115 J107 J106 J105 J102 J101 FB902 R917 R930 R918 R908 R922 R920 R220 R205 FB903 FB901 ZD902 ZD903 D902 D903 D209 D207 D205 IC903 Q207 Q205 Q902 Q901 C911 C936 C909 C204 C908 C920 C921 Q'ty 1 1 1 1 1 1 1 1 1 1 0 2 4 1 2 2 4 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 68 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 Item ViewSonic P/N Ref. P/N 556 N/A 067G 2154797NT 557 N/A 067G 3052207NT GP 558 N/A 093G 6026W52T Description LOW ESR 4.7UF+-20% 50V BY CHEM KME50VB22M-TP5 5*11 FR107 Location C207 C907 D901 Universal number# Q'ty 1 1 1 69 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1 * Reader’s Response* Dear Readers: Thank you in advance for your feedback on our Service Manual, which allows continuous improvement of our products. We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic Corporation. Assessment A. What do you think about the content of this Service Manual? Unit Excellent Good Fair Bad 1. Precautions and Safety Notices 2. Specification 3. Front Panel Function Control Description 4. Circuit Description 5. Adjustment Procedure 6. Troubleshooting Flow Chart 7. Block Diagrams 8. Schematic Diagrams 9.PCB Layout Diagrams 10. Exploded Diagram and Exploded Parts List 11. Recommended Spare Parts List B. Are you satisfied with this Service Manual? Item Excellent Good Fair Bad 1. Service Manual Content 2. Service Manual Layout 3. The form and listing C. Do you have any other opinions or suggestions regarding this service manual? Reader’s basic dada: Name: Title: Company: Add: Tel: Fax: E-mail: After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes ([email protected]) 70 ViewSonic Corporation Confidential - Do Not Copy VA502mb-1