Download SPC-8620-LVA
Transcript
Ver.1.31 Single Board Computer Half Size PCI with LAN, VGA, Audio, Video SPC-8620-LVA The SPC-8620-LVA is a PCI compatible Industrial CPU card based on VIA VT8623/VT8235 chipset and is fully designed for harsh industrial environment. It features Intel ULV/LP uFC-BGA series compatible processor. This card accommodates up to 512MB of DDR SDRAM memory. The SPC-8620-LVA comes with CPU integrate temperature sensor to protect your processor from overheating; and wired for Management (WFM) 2.0 specifications compliance. The SPC-8620-LVA has one LAN connectors that use Realtek’s RT8139D PCI LAN controller. The SPC-8620-LVA has a LCD connector that uses VT8623 integrate graphic accelerator. * Specifications, color and design of the products are subject to change without notice. Features PCI bus compatible half-size CPU board with internal LAN and VGA I/F. Intel Ultra Low Voltage Celeron 400MHz is standard with the system.(fan-less structure) Supports high-speed PC2100 DDR SDRAM for a maximum total memory of 512MB. VIA VT8623/VT8235 chipset Equip CF card slot (Type I) and the boot from CF card is possible With USB 2.0 2ch and AC97 code sound function. 5V single power supply operation SPC-8620-LVA Specification Specification Item Section Processor Ultra Low Voltage Intel(R) Celeron Processor in the 479 uFC-BGA package 400MHz, FSB 100MHz. Chipset VIA CLE266 Chipset (VT8623) + (VT8235). Cache Size On-die primary 16-Kbyte instruction cache and 16-Kbyte write –back data cache and on-die second level cache (256-Kbyte for the ULV Celeron Processor 400MHz / 512-Kbyte for the LV Pentium III Processor 800MHz) with advanced transfer cache architecture. Memory Up to 512MB PC2100 DDR SDRAM DIMM. No ECC support. Memory Sockets One 184-pin DDR SDRAM socket for SDRAM in 64MB, 128MB, 256MB and 512MB configurations. BIOS Award BIOS, PnP support Flash EEPROM (256KB) for BIOS update Power management Super I/O Winbond W83697HF. Parallel port One high-speed parallel port, SPP/EPP/ECP mode Series Port Two 16550 UART ports. 9-pin D-SUB connector x 1(RS-232C x 1) , 10-pin box header connector x 1(RS-232C/422A/485 x 1) Cable appending of 9-pin D-SUB Baud rate: 50 - 115,200bps (programmable) Enhanced IDE One EIDE port (Primary), up to 2 IDE devices, supports Ultra DMA 33/66/100/133. Compact Flash One CF memory card slot, Type I x 1, for True IDE, connect to the Secondary IDE port. FDD Interface One floppy drives (360KB, 720KB, 1.2MB, 1.44MB, 2.88MB) USB Interface One box-header support 2 USB v2.0 ports Watchdog Timer Supper I/O integrate WDT timer (1 - 255sec) and Software programmable active to Reset. Hardware Monitor Integrate supper I/O W83697HF. Keyboard One PS/2 keyboard connector on bracket and share with mouse and one connector 6-pins box-header for external keyboard. Mouse connector On bracket PS/2 Mouse connector share with keyboard. VGA Controller Integrate VT8623 frame buffer share with system memory. VGA Connector On board 15-pin D-type VGA connector. LCD 40 pin TFT LCD panel digital signal connector. LAN One Realtek RT8139D controllers, one RJ-45 connector. Wake On LAN support, Remote Boot-up Audio Support AC97 Codec RTC battery backup by Lithium Battery (CR2450) Specification CR2450 Nominal Voltage 3V Nominal Capacity 620mAh Nominal Weight 6.3g * The backup time of the CR2450 battery is over 8 years at 20°C. Form Factor PCI haft size single card. Operating System Windows XP Professional/ Home Edition Support Windows 2000 Professional Windows 98SE Windows NT Workstation Ver.4.0 *1 *1 USB is not supported. 1 Ver.1.31 Mechanical & Environmental Item POWER CONSUMPTION OPTERATING TEMPERATURE STORAGE TEMPPERATURE HUMIDITY BOARD DIMENSION BOARD WEIGHT Section Connector & Jumper Location +5VDC 4.0A max. +5VSB 1.2A max. 0 - 60°C. CN4: K/B & M/S Mini DIN JP1 - 40 - 80°C. CN2: VGA JP2 CN1: COM1 CN3: LAN 10% to 90% RH (no condensation) 186mm (L) x 123mm(H) / 7.32inch x 4.80 inch. DIMM1 300 g JP3 CN5: External K/B Accessories CN6: USB ports JP4 JP5 JP6 JP7 MEMORY MODULE PC-MDD256-184 PC-MDD512-184 JP8 184PIN DDR SDRAM 256MB, PC2100 184PIN DDR SDRAM 512MB, PC2100 CN7: COM2 FAN1 Cable USB Connector Cable USB connector cable (shielded) IPC-LCDEC-01 LCD Interface Board Extension Packing List Industrial PCI CPU board (SPC-8620-LVA) …1 User’s Manual …1 Driver disk utility (CD-ROM) ...1 IDE 66 HDD cable ...1 FDD cable ...1 Serial & Parallel cable(with bracket for attaching) ...1 Audio cable(with bracket for attaching) ...1 Keyboard converter cable ...1 Jumper pins (2.0mm) ...6 IPC Precaution List ...1 CN8: Parallel Port CN15: Primary JP13:CF IDE connector Master/Slave selector CN10: TFT connector Clear JP17: AT / ATX JP16: power selector CMOS CN11: External Battery connector CN18: CF connector (bottom side) CN9: Floppy Disk Drive FAN2 CN13: CD-Audio CN12: Audio CN16: Front panel CN14: 5V power in connector CN17: External ATX control Power Block Diagram Power Regurator 2.5V CPU Vcore PW/M circuit ( ) Inside is SPC-8622-LVA. Celeron (PentiumIII) Power Regurator 3.3V Power Regurator 1.25V Power Regurator VTT(1.5V) uFC-BGA Processor CLK GEN. ICS94227 100 (130) MHz DDR SDRAM North Bridge AC-Link V link VT8235 PCI I/F PCI BUS 10/100 LAN RL8139D RJ-45 KB/MS LPC SUPER I/O W83697HF COM1 RS232 SPC-8620-LVA Audio Connector USB#1, #2 IDE#1, #2 (CF) IDE PCI BUS Reset SW. Speaker POWER LED IDE LED AC97 Codec ALC201A USB South Bridge BIOS SST 2M or SST 39SF020A CRT Analog Display out CLE266 VT8623 TFT LCD I/F POWER Connector Reset Clock Buffer ICS93712 COM2 RS232 RS422 RS485 FDD LPT Hardware WDT Monitor 2